text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:BLACK TONER FT 4490, 887401
Preparer's Name:KRISTINA SAGE
CAGE:54726
CAGE:54726
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:MAY CAUSE TEMPORARY
DISCOMFORT. SKIN:MAY CAUSE SLIGHT IRRIT ON PRLNG & RPTD CONT.
MILDLY IRRIT (PRIMARY IRRIT INDEX 0.1. INHAL:GASPING. INGEST:>5
G/KG BODYWEIGHT, PRACTICALLY NON-TOX. CHRON IC:IN A XEROX SPONSORED
CHRONIC INHAL STUDY IN RATS USING SPECIAL TEST TONER, A VERY SLIGHT
DEGREE OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:FIBROSIS WAS NOTED IN 25% OF ANIMALS
AT MIDDLE EXPOS LEVEL (4 MG/M3) WHILE SLIGHT DEGREE OF FIBROSIS WAS
OBSERVED AT HIGHEST EXPOS LEVEL (16 MG/M3) IN ALL ANIMALS. THESE
FINDINGS ARE ATTRIBUT ED TO "LUNG OVERLOADING", GENERIC RESPONSE TO
EXCESSIVE AMTS OF ANY DUST RETAINED IN LUNGS FOR PRLNG INTERVAL.
(SUPDAT)
======================= First Aid Measures =======================
First Aid:EYES:TRY TO REMOVE W/EYE DROPS OR FLUSH W/WATER FOR AT LEAST
15 MINUTES. IF UNSUCCESSFUL, GET MEDICAL ATTENTION. SKIN:WASH
THOROUGHLY W/SOAP & WATER. INHAL:REMOVE FROM EXPOSURE.
INGEST:DILUTE STOMACH CONTENTS W/SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2, DRY CHEMICALS, FOAM OR WATER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NO SPECIAL FIRE-FIGHTING PROCEDURE IS NECESSARY.
Unusual Fire/Explosion Hazard:WILL NOT OCCUR.
================== Accidental Release Measures ==================
Spill Release Procedures:IF SPILLED, SWEEP UP USING APPRVD TONER VACUUM
CLEANER W/0.5 MICRON FILTER SUCH AS ATRIX AAA TONER VACUUM (RICOH
EDP CODE 342MIU). USE OF VACUUM CLEANER NOT RATED FOR TONER
PARTICULATE COULD BE POTNTL FIRE HAZ &/OR RSLT IN PERSONAL
INJURY.(SUPDAT).
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE REQUIRED UNDER NORMAL CONDITIONS OF USE.
Ventilation:LOCAL EXHAUST:NONE REQD UNDER NORMAL CNDTNS OF USE.
MECHANICAL (GENERAL):ADEQUATE VENTILATION.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL CONDITIONS OF
USE.
Work Hygienic Practices:CLEANSE SKIN THOROUGHLY AFTER CONTACT, BEFORE
BREAKS & MEALS & AT END OF WORK PERIODS.
Supplemental Safety and Health
EFTS OF OVEREXP:SPECIAL TEST TONER WAS 10 TIMES MORE RESPIRABLE THAN
COMMERCIALLY AVAIL TONER TO COMPLY W/EPA TESTING PROTOCOL & WOULD
NOT FUNCTION PROPERLY IN XEROGRAPHIC EQUIP. SPILL PROC:REMOVE RES
IDUE W/SOAP & WATER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>176F,>80C
Spec Gravity:0.34
Solubility in Water:NEGLIGIBLE; <0.1%
Appearance and Odor:BLACK POWDER W/SLIGHT PLASTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CARBON MONOXIDE & OTHER DECOMPOSITION
PRODUCTS IN THE CASE OF COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:USED TONER SHOULD BE DISPOSED OF IN AN
ENVIRONMENTALLY SAFE MANNER & I/A/W FED, STATE & LOC GOVT REGS. DO
NOT INCINERATE. DISP REGS VARY FROM LOCALITY TO LOCALITY,
THEREFORE, CONSULT YOUR LOC OFFICE O F EPA TO DETERMINE PROPER
METHOD OF DISP.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SODIUM PHOSPHATE MONOBASIC, 7991
Resp. Party Other MSDS Num.:S4750
CAGE:70829
CAGE:DO803
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM PHOSPHATE MONOBASIC, MONOHYDRATE; (SODIUM
BIPHOSPHATE)
CAS:7558-80-7
RTECS #:WA1900000
Minumum % Wt:98.
Maxumum % Wt:100.
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT): 8290 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: MAY CAUSE
IRRITATION TO THE RESPIRATORY TRACT. SYMPTOMS MAY INCLUDE COUGHING
AND SHORTNESS OF BREATH. INGESTION: PHOSPHATES ARE SLOWLY AND
INCOMPLETELY ABSORBED WHEN INGESTED, AND S ELDOM RESULT IN SYSTEMIC
EFFECTS. SUCH EFFECTS, HOWEVER, HAVE OCCURRED. SYMPTOMS MAY INCLUDE
VOMITING, LETHARGY, DIARRHEA, BLOOD CHEMISTRY EFFECTS, HEART
DISTURBANCES AND CENTRAL NERVOUS SYSTEM EFFECT S. THE TOXICITY OF
PHOSPHATES IS BECAUSE OF THEIR ABILITY TO SEQUESTER CALCIUM. SKIN
CONTACT: IRRITANT DUE TO ITS ACIDIC NATURE. MAY CAUSE INFLAMMATION
AND PAIN ON PROLONGED CONTACT, ESPECIALLY WITH M OIST SKIN. (EFTS
OF OVEREXP)
Effects of Overexposure:HLTH HAZ: EYE CONTACT: MAY CAUSE IRRITATION,
REDNESS AND PAIN. CHRONIC: MAY SEQUESTER CALCIUM AND CAUSE CALCIUM
PHOSPHATE DEPOSITS IN THE KIDNEYS. J.T.BAKER SAF-T-DATA RATINGS
HEALTH RATING: 1-SLIGHT. FLAMMABILITY RATING: 0-NONE. REACTIVITY
RATING: 1-SLIGHT. CONTACT RATING: 2-MODERATE. LAB PROTECTIVE EQUIP:
Medical Cond Aggravated by Exposure:NO INFORMATION FOUND.
======================= First Aid Measures =======================
First Aid:IINHALATION: REMOVE TO FRESH AIR. GET MEDICAL ATTENTION FOR
ANY BREATHING DIFFICULTY. INGESTION: GIVE LARGE AMOUNTS OF WATER TO
DRINK. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. GET
MEDICA L ATTENTION. SKIN CONTACT: IMMEDIATELY FLUSH SKIN WITH
PLENTY OF WATER FOR AT LEAST 15 MINUTES. REMOVE CONTAMINATED
CLOTHING AND SHOES. WASH CLOTHING BEFORE REUSE. THOROUGHLY CLEAN
SHOES BEFORE REUSE. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS.
EYE CONTACT: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES, LIFTING UPPER AND LOWER EYELIDS OCCASIONALLY. GET MEDICAL
ATTENTION IF IRRIT ATION PERSISTS.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE ANY MEANS SUITABLE FOR EXTINGUISHING
SURRROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT CONSIDERED TO BE AN EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF LEAK OR SPILL. WEAR
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT AS SPECIFIED IN SECTION
8. SPILL: SWEEP UP AND CONTAINERIZE FOR RECLAMATION OR DISPOSAL.
VACUUMING OR WET SWEEPING MAY B E USED TO AVOID DUST DISPERSAL.
SMALL AMOUNTS OF RESIDUE MAY BE FLUSHED TO SEWER WITH PLENTY OF
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN A TIGHTLY CLOSED CONTAINER,
STORED IN A COOL, DRY, VENTILATED AREA. PROTECT AGAINST PHYSICAL
DAMAGE. CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN EMPTY
SINCE THEY RETAIN PRODUCT RESIDUES(DUST, SOLIDS); OBSERVE ALL
WARNINGS AND PRECAUTIONS LISTED FOR THE PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR CONDITIONS OF USE WHERE EXPOSURE TO THE DUST
OR MIST IS APPARENT, A NIOSH APPROVED HALF-FACE DUST/MIST
RESPIRATOR MAY BE WORN. FOR EMERGENCIES/INSTANCES WHERE EXPOSURE
LEVELS ARE NOT KNOWN, USE A NIOSH APPROVED FULL-FACE
POSITIVE-PRESSURE, AIR-SUPPLIED RESPIRATOR. WARNING: AIR-PURIFYING
RESPIRATORS DO NOT PROTECT WORKERS IN OXYGEN-DEFICIENT ATMOSPHERES.
Ventilation:SYS OF LOCAL &/GENL EXHST IS REC TO KEEP EMPLOYEE EXPOS AS
LOW AS POSS. LOC EXHST VENT IS GENERALLY PREFERRED BECAUSE IT CAN
CONTROL EMISSIONS (SUPDAT)
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
VENT: OF THE CONTAMINANT AT IS SOURCE, PREVENTING DISPERSION OF IT INTO
THE GENERAL WORK AREA. PLEASE REFER TO ACGIH DOCUMENT, INDUSTRIAL
VENTILATION, A MANUAL OF RECOMMENDED PRACTICES, MOST RECENT ED
ITION, FOR DETAILS. PHYSICAL DATA: VAP DENS: NO INFORMATION FOUND.
================== Physical/Chemical Properties ==================
Boiling Pt:=203.9C, 399.F
Melt/Freeze Pt:=100.C, 212.F
M.P/F.P Text:LOSES WATER
Vapor Pres:NO INFO FOUND.
Vapor Density:SUPDAT
Spec Gravity:2.04
pH:4.5
Evaporation Rate & Reference:NO INFO FOUND.
Solubility in Water:59.9 G/100G @ 0C (32F)
Appearance and Odor:WHITE CRYSTALLINE POWDER; ODORLESS.
Percent Volatiles by Volume:@ 21C(70F):0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO INCOMPATIBILITY DATA FOUND.
Stability Condition to Avoid:SLIGHTLY HYGROSCOPIC.
Hazardous Decomposition Products:PHOSPHORUS OXIDES MAY FORM WHEN HEATED
TO DECOMPOSITION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:ANHYDROUS: ORAL RAT LD50: 8290 MG/KG.
===================== Ecological Information =====================
Ecological:ENVIRONMENTAL FATE: NO INFORMATION FOUND. ENVIRONMENTAL
TOXICITY: NO INFORMATION FOUND.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECOVERY/RECYCLING
SHOULD BE MANAGED IN AN APPROPRIATE & APPROVED WASTE DISPOSAL
FACILITY. PROCESSING, USE/CONTAMINATION OF THIS PRODUCT MAY CHANGE
WASTE MANAGEMENT OPTIO N. STATE & LOCAL DISPOSAL REGS MAY DIFFER
FROM FEDERAL DISPOSAL REGS. DISPOSE OF CONTAINER & UNUSED CONTENTS
I/A/W FED, STATE & LOCAL REQUIREMENTS. .
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:SODIUM BIPHOSPHATE (7558-80-7) SARA 302 RQ:
NO, TPQ: NO; SARA 313 LIST: NO, CHEMICAL CATG.: NO. SARA 311/312:
ACUTE: YES, CHRONIC: NO, FIRE: NO, PRESSURE: NO; REACTIVITY: NO
(MIXTURE/SOLID)
Federal Regulatory Information:CHEMICAL INVENTORY STATUS PART 1: SODIUM
BIPHOSPHATE (7558-80-7) TSCA:YES , EC: YES , JAPAN: YES, AUSTRALIA:
YES. CHEMICAL INVENTORY STATUS PART 2: SODIUM BIPHOSPHATE
(7558-80-7) KOREA:YES, DSL: YES , NDSL: NO, PHIL: YES. FED, ST &
INTERNATIONAL REGS PART 2: SODIUM BIPHOSPHATE CERCLA: NO, RCRA
261.33: NO, TSCA 8(D):NO. CHEMICAL WEAPONS CONVENTION: NO, TSCA
12(B): NO, CDTA: NO. WHMIS: THIS MSDS H AS BEEN PREPARED ACCORD TO
HAZ CRITERIA OF THE CTL PROD REG (CPR) AND MSDS CONTAINS ALL OF
INFO REQU IRED BY THE CPR.
State Regulatory Information:OTHER INFO: IF SWALLOWED, GIVE LARGE
AMOUNTS OF WATER TO DRINK. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. GET MEDICAL ATTENTION. PRODUCT USE: LABORATORY
REAGENT. REVSION INFORMATION: NEW 16 SECTION MSDS FORMAT, ALL
SECTIONS HAVE BEEN REVISED.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KKX37P255QAX303
CAGE:09023
CAGE:09023
CAGE:93790
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LANGE 16-8-8
CAGE:0FHH2
CAGE:0FHH2
============= Composition/Information on Ingredients =============
Ingred Name:MONOAMMONIUM PHOSPHATE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:UREA; (GRANULAR UREA)
CAS:57-13-6
RTECS #:YR6250000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:GRANULAR MURIATE OF POTASH
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CLAY; (GROUND CLAY)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CALCIUM CARBONATE; (GRANULAR LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: AT HIGH DUST CONCENTRATIONS,
IRRITATION OF EYES, SKIN & MUCOUS MEMBRANES BY CHEMICALS IN
MECHANICAL ACTION MAY OCCUR. CHRONIC: NONE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:UNDUE BREATHLESSNESS, COUGH, SPUTUM PRODUCTION.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY DISEASE
INCLUDING ASTHMA & EMPHYSEMA.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/COPIOUS AMOUNTS OF WATER. SKIN: WASH SKIN WITH
WATER & MILD DETERGENT. INHAL: REMOVE TO FRESH AIR. INGEST: DO NOT
INDUCE VOMITING. GET MED ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA NEEDED TO CONTROL SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:AT ELEVATED TEMPERATURES, UREA MAY
DECOMPOSE TO FORM CYANURIC ACID, AMMONIA BUIRET & NITROGEN OXIDES.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: IF UNCONTAMINATED RECOVER & REUSE
AS PRODUCT. LGE SPILL: PVNT LGE QTYS FROM CONTACT
W/WATERWAYS/VEGETATION. CONSULT W/STATE OR FEDERAL ENVIRONMENTAL
REGULATIONS AGENCIES FOR ACCEPTABLE DI SPOSAL PROCEDURES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP DRY OTHERWISE NO SPECIAL
PRECAUTIONS REQUIRED.
Other Precautions:SPILLED UREA, WET OR DRY, CAN CAUSE SLIPPERY
CONDITIONS. AVOID REPEATED AND PROLONGED INHALATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA APPROVED DUST RESPIRATOR SHOULD BE
WORN WHEN APPLICABLE DUST STANDARDS ARE EXCEEDED.
Ventilation:LOC EXHST: ADEQ VENT SHOULD BE AVAIL TO MAINTAIN DUST
LEVELS BELOW APPLIC STANDARD ON RESP & TOTAL NUISANCE DUST.
Other Protective Equipment:WASHING FACILITIES SHOULD BE AVAILABLE.
Work Hygienic Practices:IR IRRITATION OCCURS, LONG SLEEVES & IMPERVIOUS
Supplemental Safety and Health
SOL IN H*2O: SOLUBLE EXCEPT FOR CLAY & LIMESTONE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:275F,135C
Melt/Freeze Pt:M.P/F.P Text:275F,135C
Spec Gravity:1.9(H*2O=1)
Solubility in Water:SUPP DATA
Appearance and Odor:GRAY, WHITE, PINK & CREAM GRANULAR SOLIDS; SLIGHT
AMMONIA ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT MIX W/STRONG ACIDS AS THEY WILL REACT W/CALCIUM CARBONATE &
RELEASE CO*2 CAUSING EFFERVESCENCE WHICH (SUPDAT)
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:AMMONIUM, CYANURIC ACID, BUIRET,
NITROGEN OXIDES, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT WITH LOCAL, STATE OR FEDERAL
ENVIRONMENTAL REGTULATORY AGENCIES FOR ACCEPTABLE DISPOSAL
PROCEDURES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-46168D PART B 4:1 BLEND
Kit Part:Y
Preparer's Name:MICHAEL J LICHATOWICH
CAGE:02388
CAGE:02388
============= Composition/Information on Ingredients =============
Ingred Name:HOMOPOLYMER OF HDI
CAS:28182-81-2
RTECS #:NQ9170000
Fraction by Wt: 75%
Other REC Limits:NONE SPECIFIED
Ingred Name:HEXAMETHYLENE DIISOCYANATE *(RESIDUAL MONOMER
CONTENT LESS THAN 0.5% BASED ON RESIN SOLIDS AT TIME OF MFR.**
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: *
Other REC Limits:NONE SPECIFIED
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:**AFTER 3-6 MO STORAGE, THE FREE MONOMER CONTENT MAY RISE
(MAX 1.6). MFR ALSO RECOMMENDS A CEILING LEVEL OF 0.02 PPM.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:XYLENE (SARA 313) (VAPOR PRESSURE 7.0 MM HG @ 20C)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 12.5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:N-BUTYL ACETATE (VAPOR PRESSURE 10 MM HG @ 20C)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 12.5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM
ACGIH TLV:150 PPM/200 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC: 2.21 LB/GL
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL 4,300 MG/KG RAT. INHAL ***
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: IRRIT, REDUCED LUNG FUNCTION
(BREATHING OBSTRUCTION),LUNG DAMAGE, BRONCHITIS, BRONCHIAL SPASM,
PULMONARY EDEMA. CHEMICAL/HYPERSENSITIVE PNEUMONITIS. EYE, NOSE,
THROAT IRRIT. HIGH CONC CAN CAUSE DEATH. SOME INDIVIDUALS MAY
DEVELOP ISOCYANATE SENSITIZATION (LATER REACT W/EXPOS BELOW TLV).
MORE INFORMATION ON FILE.
Explanation of Carcinogenicity:N/K ***137 TO 1150 MG/M3 RAT. DERMAL
>1,700 MG/KG RABBIT.
Effects of Overexposure:BURNING SENSATION (NOSE, THROAT, LUNGS), RUNNY
NOSE, SORE THROAT, COUGHING, WHEEZING, ASTHMATIC ATTACK, LUNG
SENSITIVITY, CHEST DISCOMFORT, SHORTNESS OF BREATH, FEVER, CHILLS.
DRYNESS (THROAT), TIGHTN ESS (CHEST). HEADACHE, NAUSEA, NARCOSIS,
FATIGUE, LOSS OF APPETITE. REDNESS, RASH, SWELLING, SCALING,
BLISTERING. ****
Medical Cond Aggravated by Exposure:ASTHMA & OTHER RESPIRATORY
DISORDERS (BRONCHITIS, EMPHYSEMA, HYPERREACTIVITY), SKIN ALLERGIES,
ECZEMA. ****LOSS OF
COORDINATION, LOSS OF INTELLECTUAL ABILITY.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR. ADMIN OXYGEN/ARTIF RESP. CALL DR.
ASTHMATIC SYMPTOMS? TREAT SYMPTOMATICALLY. CALL DR. SKIN:REMOV
CONTAM CLOTH. WASH W/SOAP & WTR. SEVERE EXPOS, REMOVE CLOTH, GET
UNDER SAFETY SHOWER. CALL DR. LESSER EXPOS-CALL DR, IF IRRIT
DEVELOPS. EYE:FLUSH W/WTR 15 MIN, LIFT LIDS. REFER TO DR. INGEST:NO
VOMIT. 1-2 CUPS MILK/WATER. NOTHING BY MOUTH UNCONSCIOUS/CONVULSING
PERSON. CALL DR.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:91.0F,32.8C
Lower Limits:1.0
Upper Limits:7.6
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:FULL EMERG EQUIP (SCBA & FULL PROTECT CLOTH) .
DURING FIRE, HDI & OTHER TOXIC GASSES MAY BE GENERATED. ISOLATE
FROM IGNIT SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT.
Unusual Fire/Explosion Hazard:CLSD CNTNR MAY BURST WHEN CONTAM W/WATER
CREATING CO2. SOLVENT VAPOR HEAVIER THAN AIR, MAY TRAVEL ALONG
GROUND TO IGNITION SOURCE & FLASHBACK TO VAPOR SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC PEOPLE. REMOVE IGNIT SOURCES. VENT.
DIKE/STOP SPILL. NOTIFY AUTHORITIES. COVER SPILL W/ABSORB/DECONTAM
SOLUTION ON SPILL, LET REACT 10 MIN. COLLECT PROD IN CNTNR, COVER
LOOSELY, STAND 24 HR. WASHSPILL W/DECOMTAM. RESPIRATOR PROTECT
RECOMMENDED.
Neutralizing Agent:DECONTAM SOLUTIONS: NONIONIC SURFACTANT TERGITOL
TMN-10(20%) WATER(80%);#
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE: MINIMUM -30F/122F MAX. KEEP
FROM IGNITION SOURCE/HEAT. GRND CNTNRS DURING STORAGE/TRANSFER.
STORE IN CLSD CNTNRS. DO NOT RESEAL IF CONTAM.
Other Precautions:AVOID CONTACT W/SKIN & EYES. USE OF A POS PRESS AIR
SUPP RESP MAY BE NECESSARY FOR MIXING OR BRUSH APPLICATION. SEE
ADDITION INFORMATION ON FILE. FOLLOW LABEL INSTRUCT.
#CONCENTRATED AMMO NIA (3-8%) DETERGENT (2%) WATER (90-95%)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR RECOMM/APPROVED IN ISOCYANATE
CONTAINING ENVIRONMENTS MAY BE NECESSARY. USE AIR PURIFYING
RSPRTR/POSITIVE PRESSURE SUPPLIED AIR RSPRTR APPROPRIATE FOR
ISOCYANATE CONCENTRATIONS. SEE ORIGINA L MSDS ON FILE FOR FURTHER
INFORMATION.
Ventilation:EXHAUST VENT SUFF TO KEEP AIRBORNE CONC OF HDI AND
POLYISOCYANATE BELOW TLV. EXHAUST AIR MAY NEED TO BE CLEANED.
Other Protective Equipment:COVER AS MUCH SKIN AS POSSIBLE W/APPROPRIATE
CLOTHES. IF SKIN CREAMS USED, KEEP AREA PROTECTED BY ONLY CREAM TO
MINIMUM.
Work Hygienic Practices:PRECAUTIONS TO AVOID SKIN/EYE CONTACT/BREATHE
VAPOR. WASH CONTAM CLOTHING BEFORE REUSE. EYEWASH & SFTY SHOWERS
NEEDED.
Supplemental Safety and Health
OVEREXPOSURE TO CHROMIUM SOLVENT HAS BEEN ASSOCIATED W/PERMANENT
BRAIN/NERVOUS SYSTEM DAMAGE. SKIN: DEFATTING, DERMATITIS. SOLVENTS
CAN PENETRATE SKIN & CAUSE SYSTEMIC EFFECTS. INGEST: IRRITATION &
PO SSIBLE CORROSIVE ACTION IN MOUTH, INTEST TRACT. VOMITING
(ASPIRATION OF MAT'L) CAN RESULT IN CHEMICAL PNEUMONITIS.
================== Physical/Chemical Properties ==================
HCC:F5
Vapor Density:> AIR
Spec Gravity:8.85 LB/GL
Viscosity:183 MPAS @20C
Evaporation Rate & Reference:SLOWER ETHER (BU AC=1)
Solubility in Water:INSOL/REACTS W/WATER
Appearance and Odor:CLEAR TO PALE YELLOW LIQUID/SOLVENT ODOR
Percent Volatiles by Volume:CA 30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS, AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:MOISTURE, HIGH TEMPERATURES, SHOCK FROM
DROPPING.
Hazardous Decomposition Products:BY HIGH HEAT AND FIRE: CARBON DIOXIDE,
CARBON MONOXIDE, OXIDES OF NITROGEN, TRACES OF HCN AND HDI.
Conditions to Avoid Polymerization:MAY OCCUR IF IN CONTACT W/MOISTURE
OR OTHER MATERIALS WHICH REACT W/ISOCYANATES. MAY OCCUR AT
TEMPERATURES OVER 400 F.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORD W/ FEDERAL, STATE & LOCAL
ENVIRONMNTL CNTRL REGS. INCINERATION PREFERRED. IGNITABLE HAZARDOUS
WASTE (PROD RESIDUE/FLAMMABLE SOLVENT VAPOR). DECONTAMINATE CNTNRS
PRIOR TO DISPOSAL. DO N'T HEAT/CUT ON OR NEAR EMPTY CNTNRS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:UNLEADED REGULAR GASOLINE
CAGE:0MH29
CAGE:0MH29
============= Composition/Information on Ingredients =============
Ingred Name:GASOLINE
CAS:8006-61-9
RTECS #:LX3300000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:300 PPM/500 STEL
ACGIH TLV:300 PPM/500STEL;9192
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 8%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TRIMETHYL BENZENE (SARA III)
CAS:25551-13-7
RTECS #:DC3220000
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM; 9192
Ingred Name:METHYL TERT-BUTYL ETHER (SARA III)
CAS:1634-04-4
RTECS #:KN5250000
Fraction by Wt: 8%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:PRODUCT IS MILDLY IRRITATING TO BODY
TISSUES. IT MAY PRODUCE CENTRAL NERVOUS SYSTEM DEPRESSION, AND
PROLONGED AND/OR REPEATED CONTACT MAY CAUSE DERMATITIS.
Explanation of Carcinogenicity:PRODUCT CONTAINS BENZENE, LISTED BY NTP
AND IARC. REGULATED BY OSHA.
Effects of Overexposure:EYE:IRRITATION, SKIN:MILD IRRITATION,POSSIBLE
DERMATITIS WITH PROLONGED/REPEATED CONTACT. INHALED:RESPIRATORY
IRRITATION, NAUSEA, DIZZINESS, HEADACHE. INGESTED:G/I IRRITATION,
NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:PEOPLE WITH A SKIN DISORDER SHOULD
USE EXTRA CAUTION TO AVOID SKIN CONTACT WHEN HANDLING OR USING THIS
PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE. INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING IF
NECESSARY.INGESTED:D O NOT INDUCE VOMITING. GIVE 2 LARGE GLASSES
OF MILK OR WATER AND GET IMMEDIATE MEDICAL CARE. GIVE NOTHING BY
MOUTH IF UNCONSCIOUS. IF IRRITATION PERSISTS OR IS SEVERE,SEE A
DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-45F,-43C
Lower Limits:1.3
Upper Limits:6.0
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:WATER STREAM WILL SCATTER FIRE. VAPORS
ARE VERY EXPLOSIVE.
================== Accidental Release Measures ==================
Spill Release Procedures:MINOR: ABSORB MATERIAL WITH CLAY, VERMICULITE,
OR SIMILAR ABSORBENT MATERIAL. PLACE IN DISPOSAL CONTAINERS. MAJOR:
DIKE & CONTAIN SPILL. ELIMINATE SOURCES OF IGNITION. SHUT OFF
LEAKS. REMOVE LIQUID BY VACUUM OR ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, VENTILATED WORK AREA.
KEEP CONTAINERS CLOSED WHEN NOT IN USE. DETACHED STORAGE IS
PREFERABLE.
Other Precautions:'EMPTY' CONTAINERS MAY CONTAIN RESIDUE OR VAPOR.
TREAT THEM WITH THE RESPECT DUE FULL ONES. DO NOT CUT,WELD,ETC. ON
THEM. GROUND CONTAINERS BEFORE TRANSFERRING LIQUID. AVOID HAVING
OPEN ELECTRICAL EQ UIPMENT IN VAPOR AREAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR RESPIRATOR FOR
ORGANIC VAPOR IF EXPOSURE IS ABOVE THE TLV/PEL. SEE 29 CFR 1910.134
FOR REGULATIONS PERTAI NING TO RESPIRATOR USE.
Ventilation:LOCAL AND MECHANICAL EXHAUST RECOMMENDED.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICES. AVOID
PROLONGED/REPEATED CONTACT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health
CODE MUR. ON HIS LABEL, MFR LISTS SPECIFICATION AS ASTM D-439.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:82.0F,27.8C
Vapor Pres:10-15 MM
Vapor Density:3.0 - 4.0
Spec Gravity:0.72 - 0.74
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID, GASOLINE ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER HYDROCARBON COMPOUNDS DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL FEDERAL, STATE AND LOCAL
REGULATIONS. MANUFACTURER SUGGESTS THAT DISPOSAL MAY BE DONE BY
INCINERATION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INDUSTRIAL ENAMEL, 139-101 WHITE
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENTS
Fraction by Wt: 18.51%
Ingred Name:VEHICLE
Fraction by Wt: 33.33%
Ingred Name:AROMATIC HYDROCARBONS
Fraction by Wt: 48.16%
ACGIH TLV:100 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN:DRYING. EYE:IRRITATION.
INHAL:EXCESSIVE EXPOSURE MAY CAUSE ANESTHESIA, HEADACHE, NAUSEA &
UPPER RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR, APPLY ARTIFICIAL RESPIRATION IF
NECESSARY. CALL MD. SKIN:WASH W/MILD SOAP & WATER, APPLY A MILD
SKIN CREAM. IN SEVERE CASES, CALL MD. EYE:FLUSH W/WATER FOR AT
LEAST 15 MINUT ES. CALL MD. INGEST:CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:45.0F,7.2C
Lower Limits:1%
Upper Limits:7%
Extinguishing Media:FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS MAY FORM EXPLOSIVE MIXTURES W/AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:WASH W/WATER INTO RETAINING AREA OR CONTAINER.
AVOID SPARKS, FIRE OR HOT METAL SURFACES. SMALL QUANTITIES MAY BE
ABSORBED ONTO AN APPROPRIATE ABSORBANT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP COOL & AWAY FROM SOURCES OF
IGNITION. USE W/ADEQUATE VENTILATION. AVOID PROLONGED OR REPEATED
PERSONAL CONTACT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ABOVE TLV USE NIOSH/MSHA APPROVED CARTRIDGE
RESPIRATOR OR GAS MASK.
Ventilation:LOCAL EXHAUST:USE WHATEVER IS SUFFICIENT TO KEEP WORKROOM
CONCENTRATION BELOW TLV.
Other Protective Equipment:APRON & BARRIER CREAM.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:235F,113C
Vapor Pres:23 @68F
Vapor Density:3.2
Spec Gravity:1.138
Evaporation Rate & Reference:1.9 (N-BUTYL ACETATE=1)
Solubility in Water:NONE
Appearance and Odor:WHITE OPAQUE LIQUID; PUNGENT AROMATIC ODOR.
Percent Volatiles by Volume:63
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE & CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS OR DISPOSE OF
ACCORDING TO APPLICABLE LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-413-9361
Product ID: VCI-238 AEROSOL
Cage: 44695
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: INHIBITOR,CORROSION,VAPOR BARRIER
Specification Number: NONE
Type/Grade/Class: NONE
Unit of Issue: BX
Quantitative Expression: 00000000006EA
UI Container Qty: 0
Type of Container: AEROSOL CANS
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: ORAL LD50 (RAT) IS UNKNOWN
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: TARGET ORGANS: EYE, SKIN, CNS, RESPIRATORY SYSTEM ().
ACUTE AND CHRONIC - DIRECT EYE CONTACT WITH VAPORS OR LIQUID MAY CAUSE EYE
IRRITATION. PROLONGED OR REPEATED SKIN EXPOSURE CAN CAUSE MODERATE
IRRITATION AND DEFATTING OF SKIN LEADING TO POSSIBLE CHRONIC DERMATITIS.
EXCESSIVE INHAALTION OF HIGH VAPOR CONCENTRATIONS AND/OR PARTICLE MISTS OF
THIS PRODUCT MAY CAUSE LIGHT HEADEDNESS, GIDDINESS,NAUSEA, VOMITING,
SHORTNESS OF BREATH, IRRITATION OF MUCOUS MEMBRANES AND MAY LEAD TO NARCOSIS
AND CARDIAC IRREGULARITIES. INGESTION IS EXPECTED TO CAUSE GI IRRITATION.
ABSORPTION THROUGH GI TRACT MAY CAUSE SYMPTOMS SIMILAR TO INHALATION
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, DEFATTING OF SKIN, DERMATITIS,
LIGHT HEADEDNESS, GIDDINESS, NAUSEA, VOMITING, SHORTNESS OF BREATH, NARCOSIS
AND CARDIAC IRREGULARITIES
Medical Cond Aggravated By Exposure: CARDIOPULMONARY DISEASE.
First Aid: EYE CONTACT: FLUSH EYES WITH WATER FOR AT LEAST 15 MINUTES. CONSULT
A PHYSICIAN. SKIN CONTACT: WASH AFFECTED AREA WITH SOAP AND WATER. IF
IRRITATION PERSISTS, CONSULT A PHYSICIAN. INHALATION: REMOVE T O AN
UNCONTAMINATED AREA, ADMINISTER OXYGEN IF NECESSARY. IF VICTIM HAS STOPPED
BREATHING BEGIN CPR. GET MEDICAL ATTENTION. INGESTION: IFCONSCIOUS, GIVE
WATER BUT DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL ATTENTION. NOTE TO
PHYSICIAN: CAUTION: EPINEPHRINE OR OTHER STIMULANTS MAY ADVERSELY AFFECT THE
HEART.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ABSORB ON SWEEPING COMPOUND OR OTHER ABSORBENT
MATERIAL.
Waste Disposal Methods: INCINERATE OR DISPOSE OF IN ACCORDANCE WITH EXISTING
FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
Handling And Storage Precautions: CAUTION: CONTENTS UNDER PRESSURE. DO NOT
PUNCTURE OR INCINERATE. STORE AWAY FROM HEAT AND OPEN FLAMES. KEEP CONTAINERS
TIGHTLY CLOSED.
Other Precautions: AVOID EYE AND SKIN CONTACT. AVOID EXCESSIVE INHALATION OF
VAPORS OR PARTICLE MISTS. USE IN WELL VENTILATED ENVIRONMENT.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: FLAM. AEROSOL
Lower Limits: UNKNOWN
Upper Limits: UNKNOWN
Extinguishing Media: CARBON DIOXIDE OR OTHER DRY CHEMICAL FIRE FIGHTING AGENT.
Fire Fighting Procedures: FIREFIGHTER SHOULD WEAR SELF-CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard: CONTENTS OF AEROSOL CANS ARE UNDER PRESSURE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: A NIOSH APPROVED RESPIRATOR IS RECOMMENDED.
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: EYE WASH STATION.
Work Hygienic Practices: WASH HANDS AFTER USE AND BEFORE EATING, DRINKING, OR
SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health: NONE
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V3
B.P. Text: UNKNOWN
M.P/F.P Text: UNKNOWN
Decomp Text: UNKNOWN
Vapor Pres: UNKNOWN
Vapor Density: UNKNOWN
Spec Gravity: 0.7803-0.8163
PH: UNK
Evaporation Rate & Reference: UNKNOWN
Solubility in Water: UNKNOWN
Appearance and Odor: CLEAR, YELLOW LIQUID, PETROLEUM ODOR.
Percent Volatiles by Volume: UNK
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID CONTACT WITH INCOMPATIBLE MATERIALS.
Materials To Avoid: STRONG ACIDS, STRONG ALKALIS AND STRONG OXIDIZING AGENTS,
CHEMICALLY ACTIVE METALS (SODIUM, POTASSIUM, ETC.)
Hazardous Decomposition Products: OXIDES OF CARBON AND NITROGEN.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE.
=======================================================
Regulatory Information
=======================================================
Federal Regulatory Information: TSCA STATUS: LISTED.
=======================================================
Transportation Information
=======================================================
Trans ID NO: 147442
Product ID: VCI-238 AEROSOL
Review Date: 08/21/1999
Tech Entry NOS Shipping Nm: MINERAL SPIRITS, PROPANE, ISOBUTANE
Net Unit Weight: 4.69 LBS
Multiple KIT Number: 0
Unit Of Issue: BX
Container QTY: 0
Type Of Container: AEROSOL CANS
Additional Data: XXX: PER 1999 IATA REGULATIONS PSN IS : "AEROSOLS, FLAMMABLE".
N.O.S. IS NO LONGER USED BY IATA. PR OPER SHIPPING NAME, UN ID NUMBER,
HAZARD CLASS PER MSDS. GROUND AS "CONSUMER COMMODITY ORM-D", PER LABEL.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: AGC
DOT Proper Shipping Name: AEROSOLS, FLAMMABLE,
DOT PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
Hazard Class: 2.1
UN ID Num: UN1950
Label: FLAMMABLE GAS
Special Provision: N82
Non Bulk Pack: NONE
Bulk Pack: NONE
Max Qty Pass: 75 KG
Max Qty Cargo: 150 KG
Vessel Stow Req: A
Water/Ship/Other Req: 40,48,85
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: AKD
IMO Proper Shipping Name: AEROSOLS o
IMDG Page Number: 2102
UN Number: 1950
UN Hazard Class: 2(T)
IMO Packaging Group: -
Subsidiary Risk Label: T
EMS Number: 2-13
MED First Aid Guide NUM: 620
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: XXX
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ALR
AFI Symbols: *
AFI Proper Shipping Name: AEROSOLS, FLAMMABLE, N.O.S.
AFI PSN Modifier: (EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.1
AFI UN ID NUM: UN1950
Special Provisions: P4
Back Pack Reference: A6.3
=======================================================
HAZCOM Label
=======================================================
Product ID: VCI-238 AEROSOL
Cage: 44695
Company Name: THE CORTEC CORPORATION
Street: 4119 WHITE BEAR PKY
Zipcode: 55110-7634
Label Required IND: Y
Date Of Label Review: 08/21/1999
Status Code: A
Label Date: 07/31/1995
Year Procured: 1999
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: NO
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: TARGET ORGANS: EYE, SKIN, CNS, RESPIRATORY SYSTEM ().
ACUTE AND CHRONIC - DIRECT EYE CONTACT WITH VAPORS OR LIQUID MAY CAUSE EYE
IRRITATION. PROLONGED OR REPEATED SKIN EXPOSURE CAN CAUSE MODERATE
IRRITATION AND DEFATTING OF SKIN LEADINGTO POSSIBLE CHRONIC DERMATITIS.
EXCESSIVE INHAALTION OF HIGH VAPOR CONCENTRATIONS AND/OR PARTICLE MISTS OF
THIS PRODUCT MAY CAUSE LIGHT HEADEDNESS, GIDDINESS,NAUSEA, VOMITING,
SHORTNESS OF BREATH, IRRITATION OF MUCOUS MEMBRANES AND MAY LEAD TO NARCOSIS
AND CARDIAC IRREGULARITIES. INGESTION IS EXPECTED TO CAUSE GI IRRITATION.
ABSORPTION THROUGH GI TRACT M AY CAUSE SYMPTOMS SIMILAR TO INHALATION
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BUFFER P3, PLASMID STARTER KIT 12129, 12149
CAGE:01QTQ
CAGE:01QTQ
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID
CAS:64-19-7
RTECS #:AF1225000
OSHA PEL:25 MG/M3;10 PPM
ACGIH TLV:25 MG/M3;10 PPM
ACGIH STEL:37 MG/M3;15 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) 3310 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: FLAMMABLE. CAUSES SEVERE BURNS.
CORROSIVE. CAUSES BURNS.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYE CONT: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR
AT LEAST 15 MINUTES. ASSURE ADEQUATE FLUSHING BY SEPARATING EYELIDS
WITH FINGERS. SKIN CONT: IMMEDIATELY WASH WITH SOAP AND COPIOUS
AMOUNT S OF WATER. INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING
GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. INGEST: WASH OUT MOUTH WITH WATER PROVIDED PERSON IS
CONSCIOUS.
===================== Fire Fighting Measures =====================
Flash Point:=52.5C, 126.5F
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER, OR APPROPRIATE
FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:PRECAUTIONARY MEASURES: WEAR NIOSH APPRVD
PROCEDURE: ABSORB ON SAND OR VERMICULITE AND PLACE IN CLOSED
CONTAINERS FOR DISPOSAL. VENTI LATE AREA AND WASH SPILL SITE AFTER
MATERIAL PICKUP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TIGHTLY CLOSED AT 20-25C.
CORROSIVE. CAUSES BURN. DO NOT GET IN EYES, ON SKIN, OR ON
CLOTHING.
Other Precautions:THE PRODUCT SHOULD BE HANDLED WITH THE NORMAL CAUTION
ACCORDED CHEMICALS. ADDITIONAL HARMFUL PROPERTIES CANNOT BE RULED
OUT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR, FACESHIELD (8-INCH
MINIMUM).
FACESHIELD.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
WASTE DISP METH: UNLESS SPECIFIED DIFFERENTLY, NONCONTAMINATED
PACKAGING MAY BE TREATED LIKE HOUSEHOLD WASTE OR RECYCLED. DISPOSAL
MUST BE I/A/W FEDERAL, STATE, AND LOCAL REGULATIONS .
================== Physical/Chemical Properties ==================
Spec Gravity:1.123 G/CM*2
pH:5.5 @ 20C
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS LIQUID, CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE AND
CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:TOXICITY DATA: N/A. ACUTE EFFECTS. INHAL:
HARMFUL IF INHALED. MATL IS DESTRUCTIVE TO TISS OF MUC MEMB & UPPER
RESP TRACT. INHAL MAY BE FATAL AS RESULT OF SPASM, INFLAMM, & EDEMA
OFLARYNX & BRONCHI. CHEM PNEUM & PULM EDEMA. EYE CONT: MATLIS
DESTRUCTIVE. SKIN CONT: MATL IS DESTRUCTIVE. MAY BE HARMFUL IF
ABSORBED THROUGH SKIN. INGEST: HARMFUL IF SWALLOWED. PRLNGD EXPOS:
N/A. CHRONIC EFFECTS: N/A.UN R-MAN LDL0: 308 MG/KG, 85DCAL 2,73,70.
ORAL-RAT LD50: 3310 MG/KG, DMDJAP 31, 276, 59. IHL-MUS LC50: 56200
PPM/H, MELAAD 48, 559, 57. IVN-MUS LD50: 525 MG/KG, APTOA6 18, 141,
61. (ECOLOGICAL INFO)
===================== Ecological Information =====================
Ecological:NOT APPLICABLE. TOXICITY INFORMATION: SKN-RBT LD50: 1060
MG/KG UCDS 8/7/63. IRRIT DATA: SKN-HMN 50 MG/34H, MLD TSAPA9 31,
481, 75. SKIN-RBT 20 MG/24H, MOD 85JCAE-, 304, 86. EYE-RBT 5
MG/30S, RINSE MIL D TCCYAC 23, 281, 82. ONLY SELECTED REGISTRY OF
TOXIC EFTS OF CHEM SUBSTANCE (RTECS) DATA IS PRESENTED HERE. SEE
ACTUAL ENTRY IN RTECS FOR COMPLETE INFORMATION.
==================== Disposal Considerations ====================
Waste Disposal Methods:THERE ARE NO UNIFORM REGS FOR DISP OF
CHEMICALS/RESIDUES. CHEM RESIDUES GENERALLY COUNT AS SPEC WASTE. WE
RECOMMEND THAT YOU CONT EITHER AUTHS IN CHARGE/APPRVD WASTE DISP
COMPANIES WHICH WILL ADVISE Y OU ON HOW TO DISPOSE OF SPEC WASTE.
HANDLE CONTAMD PACKAGING IN SAME WAY AS SUBSTANCE ITSELF. (SUPDA T)
===================== Regulatory Information =====================
Federal Regulatory Information:LABELING: C, CORROSIVE, R 34.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-1440, PART B
Kit Part:Y
Preparer's Name:JCS
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:PHENOL POLYMER WITH FORMALDEHYDE (PHENOLIC RESIN)
CAS:9003-35-4
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC: 0 G/L (MIXED)
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. MAY CAUSE
ALLERGIC SKIN RASH IN SENSITIZED INDIVIDUALS. INHALATION: THROAT
IRRITATION. INGESTION: MAY CAUSE NAUSEA, VOMITING, KIDNEY AND LIVER
DAMAGE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LUKEWARM WATER FOR 15 MINUTES. IF SYMPTOMS
PERSIST, CONSULT PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. IF
SYMPTOMS PERSIST, CONSULT A PHYSICIAN. INHALATION: REMOVE TO FRESH
AIR. IF SY MPTOMS ARE PRESENT, CONSULT A PHYSICIAN. INGESTION: GIVE
MILK OR WATER TO DRINK. CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP INTO CONTAINERS. CLEAN-UP RESIDUE WITH
1,1,1-TRICHLOROETHANE.
============= Exposure Controls/Personal Protection =============
Ventilation:GENERAL VENTILATION
Supplemental Safety and Health
KEY1:N1.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NA
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:1.60
Evaporation Rate & Reference:NA
Solubility in Water:NEGLIGIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Hazardous Decomposition Products:SO2, CO, CO2, H2S AND POSSIBLE
FORMALDEHYDE
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT A HAZARDOUS WASTE ACCORDING TO EPA
REGULATIONS. CONSULT STATE REGULATIONS PRIOR TO DISPOSAL OF
SPILLAGE.
| 1 | gloves_mandatory |
=======================================================
Product ID: DOT 3-STANDARD HEAVY DUTY BRAKE FLUID, M44-34
Cage: 77628
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 77628
Box: 34689
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EYES: IRRITANT. SKIN: MILDLY IRRITATING ON
PROLONGED EXPOSURE. INHALATION: EXCESSIVE INHALATION OF MIST OR FUMES MAY
CAUSE IRRITATION TO MUCOUS MEMBRANES. INGESTION: HARMFUL IF SWALLOWED. MAY C
AUSE STOMACH CRAMPS, NAUSEA, DIARRHEA. CHRONIC: NONE SPECIFIED BY
MANUFACTURER.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES THOROUGHLY WHILE
LIFTING EYELIDS. IF ADVERSE EFFECTS PERSIST, CONSULT MD IMMEDIATELY. SKIN:
WASH WITH SOAP AND WATER THOROUGHLY. REMOVE CONTAMINATED CLOT HING AND
LAUNDER BEFORE REUSE. INHALATION: MOVE TO FRESH AIR. INGESTION: DRINK TWO
GLASSES OF WATER. INDUCE VOMITING! GET MEDICAL ATTENTION. CONSULT MD
IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OBSERVING HEALTH HAZARDS DESCRIBED ABOVE, VENTILATE
AREA, REMOVE IGNITION SOURCES. CONFINE SPILL, FLUSH WITH WATER, WIPE UP WITH
RAGS, TRANSFER TO WASTE DRUM.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE GOVERNMENT
LAWS AND REGULATIONS. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS (FP N).
Handling And Storage Precautions: STORE AWAY FROM SPARKS, FLAMES, OXIDIZING
AGENTS AND ALKALIS.
Other Precautions: WEARING CONTACT LENSES IS INADVISABLE! KEEP AWAY FROM
CHILDREN AND ANIMALS!
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point Text: 300F,149C
Extinguishing Media: WATER FOG, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE KNOWN.
=======================================================
Control Measures
=======================================================
Ventilation: USE WITH ADEQUATE VENTILATION. BULK HANDLING (PROLONGED EXPOSURE):
GENERAL.
Other Protective Equipment: EMERGENCY EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: SPEC GRAV: 0.95-1.0 (H*2O=1).
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >410F,>210C
Spec Gravity: SUP DAT
PH: 8.5-10
Solubility in Water: SOLUBLE
Appearance and Odor: LIGHT, YELLOW TO DARK AMBER LIQUID WITH MILD ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: OXIDIZING AGENTS AND ACIDS.
Hazardous Decomposition Products: BY FIRE: NORMAL PRODUCTS OF COMBUSTION:
CARBON DIOXIDE, CARBON MONOXIDE AND SMOKE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: DOT 3-STANDARD HEAVY DUTY BRAKE FLUID, M44-34
Cage: 77628
Company Name: RADIATOR SPECIALTY COMPANY
Street: 1900 WILKINSON BLVD.
PO Box: 34689
Zipcode: 28208
Label Required IND: Y
Date Of Label Review: 11/11/1998
Status Code: C
Label Date: 11/11/1998
Origination
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYES: IRRITANT. SKIN: MILDLY IRRITATING ON
PROLONGED EXPOSURE. INHALATION: EXCESSIVE INHALATION OF MIST OR FUMES MAY
CAUSE IRRITATION TO MUCOUS MEMBRANES. INGESTION: HARMFUL IF SWALLOWED. MAY C
AUSE STOMACH CRAMPS, NAUSEA, DIARRHEA. CHRONIC: NONE SPECIFIED BY
MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WALLKOLOR, 3650
Preparer's Name:J BURNWORTH
CAGE:9H480
CAGE:9H480
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA) VP:0.8 @68C
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 3%
OSHA PEL:50 PPM (MFR)
ACGIH TLV:C 50 PPM,VAPOR; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: OVER EXPOSURE MAY CAUSE
HEADACHE, NAUSEA, SKIN AND EYE IRRITATION. INHAL: HIGH
CONCENTRATIONS OF VAPORS MAY CAUSE HEADACHE, NAUSEA AND IRRITATION
OF THE NOSE, THROAT, AND LUNGS. SKIN & EYES: CO NTACT MAY CAUSE
IRRITATION OR BURNING OF THE EYES. REPEATED LIQUID CONTACT MAY
CAUSE SKIN IRRITATION (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: AND DERMATITIS. INGESTION: SWALLOWING
CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND
DIARRHEA. VOMITING CAN RESULT IN ASPIRATION OF MATERIAL INTO THE
LUNGS WHICH CAN CAUSE CHEMI CAL PNEUMONITIS. CHRONIC: UNPROTECTED
OVER EXPOSURE TO MISTS FROM SPRAY APPLICATION MAY CAUSE LUNG
DISEASE (SILICOSIS).
Medical Cond Aggravated by Exposure:NONE KNOWN AT THIS TIME.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED,
APPLY ARTIFICIAL RESPIRATION. CONSULT A PHYSICIAN. EYE: WASH WITH
CLEAN WATER FOR AT LEAST 15 MINUTES. CONSULT A PHYSICIAN. SKIN:
WASH AFFECT ED AREAS WITH SOAP AND WATER. REMOVE CONTAMINATED
CLOTHING. CONSULT A PHYSICIAN. INGESTION: DRINK 1 OR 2 GLASSES OF
WATER TO DILUTE. CONSULT A PHYSICIAN OR POISON CONTROL CENTER
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Lower Limits:3.2%
Upper Limits:15.2%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD UP AND EXPLOSION WHEN EXPOSED
TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. PREVENT SKIN AND EYE CONTACT
AND BREATHING OF VAPOR. CONTAIN AND REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 200F.
Other Precautions:DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED FOR BRUSH AND ROLL APPLICATION. FOR
SPRAY APPLICATION, WEAR A PROPERLY FITTED NIOSH (TC-23C) APPROVED
VAPOR/PARTICULATE RESPIRATOR UNTIL ALL VAPORS AND SPRAY MIST ARE
EXHAUSTED.
Ventilation:PROVIDE SUFFICIENT VENT IN VOL & PATTERN TO KEEP AIR CONTAM
CONC BELOW APPLIC OSHA PEL/ACGIH TLV OCCUP EXPOSURE (SUPDAT)
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
DAT)
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING THE RESTROOM.
Supplemental Safety and Health
VENT: LIMIT (SECTION). OTHER PROT EQUIP: PROTECTIVE CREAMS MAY BE USED
FOR EASE OF CLEAN-UP, NOT FOR PROTECTION.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE INGRED
Vapor Density:LTR/AIR
Spec Gravity:1.36 (H*2O = 1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:DILUTABLE
Appearance and Odor:COLORED LIQUID WITH AN AMMONIACAL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN AT THIS TIME.
Stability Condition to Avoid:DO NOT HEAT ABOVE 200F.
Hazardous Decomposition Products:NONE KNOWN AT THIS TIME.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. ABSORB LARGE SPILLS WITH SAND, CLAY OR DIATOMACEOUS
EARTH. DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL DISPOSAL
REQUIREMENTS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:853A 1005
Preparer's Name:PAUL PFEIFER
CAGE:DO714
CAGE:DO714
CAGE:77416
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:EYES: MAY IRRI. SKIN: SKIN IRRI UPON
PROLONGED/REPEATED CONTACT. & SYS EFFECTS: RESPIRATORY TRACT
IRRITATION. & CENTRAL NERVOUS SYSTEM DEPRESSION IN HIGH
CONCENTRATIONS
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/LARGE QUANT OF WTR 15 MIN & SEEK IMMED MED ATTN.
SKIN: WASH W/SOAP & LARGE QUANT OF WTR. SEEK MED ATTN., IF IRRI
PERSISTS. INHAL: IF BREATH IF DIFFDIZZ, OR LIGHTHEADEDNESS OCCURS,
SEEK AI R FREE OF VAPORS. IF BREATH STOPS, BEGINCPR & SEEK IMMED
MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:101 F/ 38.33 C
Extinguishing Media:USE FOAM, CO2 OR DRY CHEMICAL FIRE FIGHTING
APPARATUS
Fire Fighting Procedures:SELF CONTAINED BREATHING APPARATUS IS
RECOMMENDED FOR FIRE FIGHTERS. WTR MAY BE UNSUITABLE AS EXTING
MEDIA, HELPFUL IN COOLING CONT. AVOID SPREAD OF BURNING LIQ
Unusual Fire/Explosion Hazard:KEEP WORK AREAS FREE OF HOT METAL
SURFACES & OTHER SOURCES OF IGNITION
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SOURCES OF IGNITION & HOT METAL SURFACES
ISOLATED FROM THE SPILL. FLUSH SPILLED MATERIAL INTO SUITABLE
RETAINING AREAS/CONTAINERS W/LARGE QUANT OF WTR. SML: AMTS OF SPILL
MATERIAL ABSORBED INTO A N APPROPRIATED ABSORBANT
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PRODUCT CONTAINERS COOL, DRY, &
AWAY FROM SOURCES OF IGNITION. USE & STORE THIS PRODUCT WITH
ADEQUATE VENTILATION.
Other Precautions:PERSONNEL SHOULD AVOID INHAL OF VAPORS. IF CONTACT
WITH THE PRODUCT SHOULD BE AVOIDED. SHOULD CONTACT BE MADE, REMOVE
SATURATED CLOTHING AND FLUSH AFFECTED AREAS WITH WATER
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DEPENDS ON VAPOR CONCENTRATION ABOVE THE
TIME-WEIGHTED TLV; USE A NIOSH APPROVEDCARTRIDGE RESPIRATOR OR GAS
MASK
Ventilation:GENERAL MECH VENT MAY BE SUFFICIENT, IF NOT LOCAL EXHAUST
MAY BE REQUIRED. RESPIRATORY MASKS/ENVIR CONTAINMENT DEVICES
Other Protective Equipment:IMPERMEABLE APRONS ARE ADVISED, AVAILABLE
EYE WASH AND SAFETY SHOWERS IN WORK AREAS IS RECOMMENDED
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:310 - 405 F
Vapor Density:> AIR
Spec Gravity:< THAN WATER
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, HAS LITTLE IF ANY COLOR AND HAS A
CHARACTERISTIC ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS, STRONG ACIDS OR BASES &
SELECTED AMINES
Hazardous Decomposition Products:THERMAL DECOMP IN THE PRESENCE OF AIR
MAY YIELD CARBON MONOXIDE &/OR CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORD WITH APPLICABLE LOCAL,
COUNTYSTATE AND FEDERAL REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AUTOCOAT LV MM TONER JET BLACK 005328
Preparer's Name:AKZO CAR REFINISH MFG DPT
CAGE:AKZNB
CAGE:AKZNB
CAGE:TO942
============= Composition/Information on Ingredients =============
Ingred Name:AROMATIC SOLVENT. (VAPOR PRESSURE: N.AV, LD50 (ORAL, RAT):
N.AV, LD50 (DERM,RABBIT): N.AV, LC50 (INHAL, RAT): N..AV, LEL:
N.AV, MFR CAS NO. 000)
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:N.AV.
ACGIH TLV:100 PPM
Ingred Name:BUTYL ACETATE. (VAPOR PRESSURE: 8.0, LD50 (ORAL,RAT): 10768
MG/M3, LD50 (DERM,RABBIT): 17600 MG/M3, LC50 (INHAL,RAT): 2000
MG/M3, LEL: 1.7)
CAS:123-86-4
RTECS #:AF7350000
Minumum % Wt:10.
Maxumum % Wt:25.
OSHA PEL:710 MG/M3;150 PPM
ACGIH TLV:713 MG/M3;150 PPM
ACGIH STEL:950 MG/M3;200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYLBENZENE. (VAPOR PRESSURE: 7.1, LD50 (ORAL, RAT): 3500
MG/M3, LD50 (DERM, RABBIT): 15486 MG/M3, LC50 (INHAL,RAT): N.AV.,
LEL: 1.0)
CAS:100-41-4
RTECS #:DA0700000
= Wt:.9
OSHA PEL:435 MG/M3;100 PPM
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:543 MG/M3;125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE-MIXED ISOMERS. (VAPOR PRESSURE: 5.1, LD50 (ORAL,
RAT): 4300 MG/M3, LD50 (DERM,RABBIT): >1700 MG/M3, LC50 (INHAL,
RAT): 5000 MG/M3, LEL: 1.0)
CAS:1330-20-7
RTECS #:ZE2100000
= Wt:3.4
OSHA PEL:100 PPM
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL AMYL KETONE. (VAPOR PRESSURE: 2.1, LD50 (ORAL, RAT):
1670 MG/M3, LD50 (DERM, RABBIT): 10286 MG/M3, LC50 (INHAL, RAT):
2000 MG/M3, LEL: 1.1)
CAS:110-43-0
RTECS #:MJ5075000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:465 MG/M3;100 PPM
ACGIH TLV:233 MG/M3;50 PPM
Ingred Name:CARBON BLACK. (VAPOR PRESSURE: N.AP, LD50 (ORAL,RAT): N.AV,
LD50 (DERM,RABBIT): N.AV, LC50 (INHALATION, RAT): N.AV, LEL: N/AP).
CAS:1333-86-4
RTECS #:FF5800000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:PROPYLENE GLYCOL METHYL ETHER ACETATE. (VAPOR PRESSURE:
3.4, LD50 (ORAL, RAT): 8532 MG/M3, LD50 (DERMAL, RABBIT): 5000
MG/M3, LC50 (INHAL, RAT): N.AV., LEL: 1.5.)
CAS:108-65-6
RTECS #:AI8925000
Minumum % Wt:1.
Maxumum % Wt:5.
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:PRIMARY ROUTES OF ENTRY: INHALATION,
SKIN CONTACT, INGESTION, EYES. ACUTE: INHALATION: NASAL & RESP
IRRIT, NAUSEA, COUGH, DIZZINESS, WEAKNESS, HEADACHE, DROWSINESS,
FATIGUE, CHEST PAIN, VOMITING, CNSEFFECTS, ASPHYXIATION, LACK OF
COORDINATION. SKIN CONTACT: EXTRACTION OF NATURAL OILS WITH
RESULTING DRY SKIN, IRRIT, REDNESS & DERMATITIS. CAN BE ABSORBED
THROUGH THE SKIN INTO THE BLOOD. EYE:: IRRIT ATION, REDNESS, PAIN,
BLURRED VISION, SENSATION OF SEEING HALOS AROUND LIGHTS &
REVERSIBLE DAMAGE. INGESTION: GI IRRITATION, NAUSEA, VOMITING,
DIARRHEA, DROWSINESS, LACK OF COORDINATION, CNS EFFECTS,
DEPRESSION (OVEREXPOSURE)
Explanation of Carcinogenicity:ETHYLBENZENE: IARC GROUP 2B (POSSIBLY
CARCINOGENIC TO HUMANS), VOLUME 77, PAGE 227, 2000. CARBON BLACK:
IARC GROUP 2B, VOL 65, PAGE 149, 1996. CARBON BLACK HAS BEEN SHOWN
TO CAUSE CANCER IN LABORATORY ANIMALS BY INHALATION AND IS LISTED
AS A SUSPECT CARCINOGEN BY IARC.
Effects of Overexposure:HEALTH HAZARD (CON'T): CHRONIC: REPEATED
OVEREXPOSURE MAY CAUSE CNS DAMAGE, KIDNEY DAMAGE, LIVER
ABNORMALITIES, LUNG DAMAGE, REPRODUCTIVE ORGAN DAMAGE, BLOOD
EFFECTS, DERMATITIS. OTHER HEALTH EFFECTS : INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING CONTENTS MAY BE HARMFUL OR
FATAL. REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED OCCUPATIONAL
OVEREXPOSURE TO SOLVENTS WITH PERMANENT BR AIN & NERVOUS SYSTEM
DAMAGE. EMERGENCY OVERVIEW: NAUSEA, COUGH, DIZZY, WEAKNESS,
HEADACHE, CHEST PAIN, LACK OF COORDINATION, SHORTNESS OF BREATH,
DERMATITIS, REDNESS &/OR PAIN IN EYES.
Medical Cond Aggravated by Exposure:SKIN DISORDERS, LIVER CONDITIONS,
KIDNEY CONDITIONS, NEUROLOGICAL DISORDERS, PREGNANCY, REPRODUCTIVE
SYSTEM DISORDERS.
======================= First Aid Measures =======================
First Aid:IN ALL CASES IF SYMPTOMS PERSIST, SEEK MEDICAL ATTENTION.
INHALATION: MOVE TO FRESH AIR, GIVE ARTIFICIAL RESPIRATION IF
NECESSARY. SKIN CONTACT: REMOVE CONTAMINATED CLOTHING, WASH WITH
SOAP AND WATER OR RECOGNIZED SKIN CLEANER. DO NOT USE SOLVENTS OR
THINNERS. EYE CONTACT: CONTACT LENSES MUST BE REMOVED, FLUSH WITH
WATER FOR AT LEAST 15 MINUTES, CONSULT A PHYSICIAN IMMEDIATELY.
INGESTION: DRINK ON E OR TWO GLASSES OF WATER TO DILUTE. DO NOT
INDUCE VOMITING. CONSULT A PHYSICIAN OR POISON CONTROL CENTER
IMMEDIATELY. TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:=26.7C, 80.F
80-92F (27-33C).
Lower Limits:0.9
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL OR WATER FOG OR
SPRAY. WATER JET OR STREAM IS UNSUITABLE. NFPA 704: HEALTH-2,
FLAMMABILITY-2, REACTIVITY-0.
Fire Fighting Procedures:WATER SHOULD BE USED TO COOL CONTAINERS
EXPOSED TO FIRE. FIRE FIGHTING PERSONNEL SHOULD WEAR NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE EQUIPMENT .
NFPA FLAMMABILITY/C LASS: 1C. FLAMMABLE LIQUID, REFER TO GUIDE 127
OF THE NORTH AMERICAN EMERGENCY GUIDE BOOK. PRODUCT USE: COLOR
COAT.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. FIRE WILL PRODUCE DENSE BLACK SMOKE
CONTAINING HAZARDOUS PRODUCTS OF COMBUSTION. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT. OBTAIN MEDICAL AT TN. FORMS EXPLOSIVE MIXTURE
WITH AIR. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL TO A SOURCE OF
IGNITION AND FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS, VENTILATE CONFINED AREA. DIKE TO REDUCE EXTENT OF
SPILL. REMOVE WITH INERT ABSORBENT (VERMICULITE, CLAY, OIL-DRY,
KITTY LITER, ETC) USING NON-SP ARKING TOOLS.TRANSFER TO A GROUNDED
METAL CONTAINER, SEAL CONTAINER. DISPOSE OF AS HAZARDOUS WASTE. IF
NECESSARY REPORT TO APPLICABLE GOVERNMENT AGENCY.
======================Handling and Storage ======================
Handling and Storage Precautions:USE APPROVED BONDING & GROUNDING
PROCEDURES WHEN TRANSFERRING LIQUID TO ANOTHER CONTAINER. DO NOT
TRANSFER TO UNLABELED CONTAINERS. NO SMOKING. STORE PLASTIC CNTNRS
OF FLAMMABLE LIQUIDS INSIDE CLOSEDAPPROVED BOXES OR SAFETY
CABINETS. STORE CNTNRS OUT OF SUN, AWAY FROM HEAT, SPARKS & (OTHER
PREC)
Other Precautions:HNDLG/STOR (CONT): OPEN FLAMES. CLOSE ALL CONTAINERS
AFTER EACH USE. CONSULT NFPA & LOCAL CODES FOR MORE STORAGE
REQUIREMENTS. VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL ALONG FLOOR.
USE EXPLOSION PROOF EQUIP IN AREA WHERE THERE IS SPRAYING/OPEN
CONTAINERS. DO NOT TAKE INTERNALLY. OBSERVE LABEL PRECAU
TIONS.(OTHER INFO)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN PERSONNEL, WHETHER SPRAYING OR NOT, ARE
INSIDE SPRAY BOOTH, VENTILATION IS UNLIKELY TO BE SUFFICIENT TO
CONTROL PARTICULATES & CHEM VAPOR IN ALL CASES. IN SUCH CASES NIOSH
APPROVED AIR SUPPLIED R ESP EQUIPMENT RECOMMENDED UNTIL PARTICULATE
& VAPOR CONC HAS FALLEN BELOW EXPOSURE LIMITS. IF MONITORING
DEMONSTRATES LEVEL BELOW TLV/PEL WEAR(OTHER PROT EQUIP)
Ventilation:PROVIDE SUFFICIENT VENTILATION TO KEEP VAPOR CONCENTRATIONS
BELOW GIVEN TLV &/OR PEL. FOR BAKING FINISHES, EXHAUST VAPORS
EMITTED DURING HEATING. (SUPP SAFETY)
FACESHIELD .
Other Protective Equipment:ANTI STATIC PAINT SUIT. EYEWASH AND DELUGE
SHOWER MEETING ANSI DESIGN CRITERIA . RESP PROT (CONT): NIOSH
APPROVED RESPIRATOR DEVICE. SEE SAFETY EQUIP SUPPLIER FOR
RECOMMENDATION & (HYGIENE PRAC)
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING THE
WASHROOM. LAUNDER CLOTHING BEFORE REUSE. OTHER PROT EQUIP (CONT):
EVALUATION &. WEAR ORGANIC VAPOR CARTRIDGE RESP WHEN HANDLING.
Supplemental Safety and Health
VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL ALONG FLOORS. MATERIAL HAS
OFFENSIVE ODOR. PROLONGED EXPOS MAY REDUCE THE USER'S SENSITIVITY
TO THE ODOR, THUS REDUCINGEFFECTIVENESS OF ODOR AS A WARNING AGA
INST EXPOSURE. VENTILATION (CONT): REMOVE DECOMP PROD FORMED
DURING WELDING/FLAME CUTTING OF SURFACES COATED W/PROD.
================== Physical/Chemical Properties ==================
Boiling Pt:=93.3C, 200.F
B.P. Text:RANGE: 200-380F (93-19
Vapor Density:> AIR.
Spec Gravity:0.97 - 1.54.
VOC Grams/Liter:3.
Evaporation Rate & Reference:SLOWER THAN ETHER.
Appearance and Odor:COLORED LIQUID. ORGANIC ODOR.
Percent Volatiles by Volume:40 - 42.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ALKALI METALS, HYDROGEN FLUORIDE, NITRIC ACID, SODIUM
HYDROXIDE.
Stability Condition to Avoid:HEAT, OPEN FLAMES, SPARKS. WASTE DISPOSAL
(CONT): WHEN DISCARDED IN ITS SUPPLIED FORM, PRODUCT MEETS HAZARD
CRITERIA OF 'IGNITABILITY' & MUST BE CONSIDERED AS HAZARDOUS WASTE
D001.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN, VARIOUS
HYDROCARBONS, TOXIC FUMES.
=================== Toxicological Information===================
Toxicological Information:CARCINOGENICITY: THIS PRODUCT CONTAINS
ETHYLBENZENE. A DRAFT REPORT ON A STUDY CONDUCTED BY THE NTP
STATES THAT LIFETIME INHALATION EXPOSURE OF RATS & MICE TO
CONCENTRATIONS OF ETHYLBENZENE (750 PPM) RESULTED IN INCREASES IN
CERTAIN TYPES OF CANCER, INCLUDING KIDNEY TUMORS IN RATS & LUNG &
LIVER TUMORS IN MICE. THESE EFFECTS WERE NOT OBSERVED IN ANIMALS
EXPOSED TO LOWER CONCENTRATIONS OF ETHYLBEN ZENE (75 PPM OR 250
PPM). THE DRAFT REPORT DOES NOT ADDRESS THE RELEVANCE OF THESE
RESULTS TO HUMANS. SENSITIZATION: THIS PRODUCT MAY CAUSE SKIN &
INHALATION SENSITIZATION TO CERTAIN INDIVIDUALS. TERA TOGENICITY:
NONE KNOWN. (STATE REG)
===================== Ecological Information =====================
Ecological:GENERAL INFORMATION: AVOID RUNOFF INTO GROUND, STORMS OR
SEWERS WHICH LEAD INTO WATERWAYS. WATER RUNOFF CAN CAUSE
ENVIRONMENTAL DAMAGE. ENVIRONMENTAL IMPACT DATA (PERCENTAGE BY
WEIGHT): N/P. VOC: SEE PHYSICAL/CHEMICAL. OZONE DEPLETORS: NONE.
HEAVY METALS: NONE. US FEDERAL HAZARDOUS AIR POLLUTANTS: XYLENE,
ETHYLBENZENE. SEE INDIVIDUAL COMPOSITIONS. THERE ARE EXTENSIVE
ECOLOGICAL DATA AVAILABLE ON THE VARIOUS COMPONENTS OF THIS
PRODUCT. AN ADEQUATE REPRESENTATION OF ALL THESE DATA IS BEYOND THE
NUMBER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FEDERAL, STATE, PROVINCIAL & LOCAL
POLLUTION REQUIREMENTS. IN ADDITION, RAGS, SPRAY BOOTH FILTERS,
PAINT SUITS, EMPTY CANS, ETC., CONTAMINATED WITH PRODUCT MAY BE
HAZARDOUS WASTE. DETERMIN E WHETHER CONTAMINATED ITEMS ARE
HAZARDOUS & DISPOSE OF AS APPROPRIATE. CLEAN PREFERABLY W/DETERGENT
, AVOID USING SOLVENTS. (CONDITIONS TO AVOID)
=================== MSDS Transport Information ===================
Transport Information:GROUND SHIPMENTS: FOR INNER CONTAINERS OF 5L OR
LESS USE ONLY PROPER AKZO NOBEL OR UN SPECIFIED OUTER CONTAINERS.
POSITIVELY CLOSE ALL SEAMS. SHIPPER MUST BE TRAINED & CERTIFIED TO
HANDLE HAZARDOUS MA TERIALS IN GROUND TRANSPORTATION (DOT/TDG). FOR
CONTAINERS GREATER THAN 5L USE 1A1 CONTAINERS. PROPER SHIPPING
NAME: PAINT. HAZARD CLASS/DIVISION: 3. UN IDENTIFICATION #: UN1263.
PACKAGING GROUP: III. HAZARD LABEL: FLAMMABLE LIQUID. OCEAN
SHIPMENTS: FOR INNER CONTAINERS OF 5L OR LESS USE ONLY AKZO NOBEL
OR UN SPECIFICATION CONTAINERS. POSITIVELY CLOSE ALL SEAMS. FOR
CONTAINERS OF OVER 5L USE 1A1 C ONTAINERS.SHIPPER MUST BE (SARA)
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302 EXTREMELY HAZARDOUS SUBSTANCES:
NONE. SECTION 311/312 HAZARD CATEGORIES: IMMEDIATE HEALTH, DELAYED
HEALTH, FIRE HAZARD. SECTION 313 TOXIC CHEMICALS: ETHYLBENZENE &
XYLENE. TRANSPORT (CONT) :TRAINED & CERTIFIED TO HANDLE HAZARDOUS
MATERIAL IN MARINE TRANSPORTATION (IMO/IMDG). PROPER SHIPPING NAME:
PAINT. UN ID #: UN1263. PACKAGING GROUP: III. HAZARD LABEL:
FLAMMABLE LIQUID. HAZARD CLASS/ DIVISION: 3.3. IMDG PAGE (ENGLISH
TRANSLATION):3372. MARINE POLLUTANT: NO. AIR SHIPMENTS: PRODUCTS OF
5L OR LESS MUST BE REPACKAGED FOR AIR TRANSPORTATION INTO UN
SPECIFICATION OUTER PACKAGINGS DESIGN ED FOR TRANSPORTATION BY AIR.
(FED REG)
Federal Regulatory Information:OSHA: THIS PRODUCT IS CONSIDERED
HAZARDOUS UNDER THE FEDERAL OSHA HAZARD COMMUNICATION STANDARD.
WHMIS: B2:D1A; D2A. TSCA STATUS: ALL INGREDIENTS ARE TSCA
REGISTERED. CEPA STATUS: ONE INGREDIENT IS NO T LISTED ON THE DSL
OR NDSL. SARA (CONT): SHIPPER MUST BE TRAINED & CERTIFIED TO SHIP
HAZARDOUS MATERIAL IN AIR TRANSPORTATION (ICAO/IATA). PROPER
SHIPPING NAME: PAINT. HAZARD CLASS OR DIVISION: 3. UN ID#: UN1263.
PACKAGING GROUP: III. HAZARD LABEL: FLAMMABLE LIQUID. PACKAGING
INSTRUCTIONS PASSENGER AIRCRAFT (IATA ENGLISH TRANSLATION):309 OR
Y309. PACKAGING INSTRUCTIONS CARGO AIRCRAFT (IATA ENGLISH
TRANSLATION): 310. (STATE REGS)
State Regulatory Information:PROPOSITION 65: WARNING! THIS PRODUCT
CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFLORNIA TO CAUSE
CANCER: CARBON BLACK. FED REGS (CONT): SPECIAL PROVISIONS: A3, A7,
A72. ALSO YOU MAY BE AFFECTED BY OTHER SECTIONS OF THE LAW,
DEPENDING ON CHEMICALS & AMOUNTS THAT INVENTORY AT YOUR LOCATION.
TOXICOLOGICAL(CONT): REPRODUCTIVE TOXICITY: NONE KNOWN. THRESHOLD
LIMIT VALUE: NONE ESTABLISHED FOR THIS P RODUCT. FOR FURTHER
(CONT): BARRIER CR EAMS ARE NOT SUBSTITUTES FOR FULL PHYSICAL PROT.
======================= Other Information =======================
| 1 | gloves_mandatory |
=======================================================
Product ID: SOLID TIMBER STAIN (458 LINE), 458312 (VII)
Cage: 85519
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 85519
Box: 600
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:INHAL:IRRIT OF RESP TRACT. PRLNG INHAL MAY LEAD TO
FATG, DROW, DIZZ &/LT HEAD, HDCH, LACK OF COORD, NAUS, VOMIT, CNS
DEPRESS, ANESTH EFT/NARCOS. SKIN:IRRIT. PRLNG/RPTD CONT CAN CAUSE DERM, DEFAT
. EYE:IRRIT. PRLNG/RPTD CONT CAN CAUSE BLURRED VISION, REDNESS, TEARING, SEV
IRRIT. INGEST:AMTS INGEST (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: INCIDENTAL TO CONSUMER &
INDUS HNDLG ARE NOT LIKELY TO CAUSE INJURY. HOWEVER, INGEST OF LARGER AMTS
MAY CAUSE LUNG INFLAMM & DMG DUE TO ASPIR OF MATL INTO LUNGS. NOTICE:
REPORTS HAVE ASSOC R PTD/PRLNG OCCUP OVEREXP TO SOLVS W/PERMBRAIN & CNS
DMG. INTENTIONAL MISUSE BY DELIBERATELY CONC & INHALING (SUP DAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: REMOVE TO FRESH AIR. RESTORE & SUPPORT BRTHG. HAVE
TRAINED PERS GIVE OXYGEN IF NEC. GET EMER MED ATTN. SKIN: WASH OFF QUICKLY
W/PLENTY OF WATER, THEN SOAP & WATER. REMOVE CONTAM CLTHG. WASH CON TAM
CLTHG BEFORE REUSE. EYE: FLUSH IMMED W/LGE AMTS OF WATER, ESPECIALLY UNDER
LIDS, FOR AT LEAST 15 MIN. OBTAIN EMER MED TREATMENT. INGEST: IF SWALLOWED,
OBTAIN MED TREATMENT IMMED.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION (FLAME, HOT SURFACES,
AND ELECTRICAL, STATIC SPARKS). VENTILATE AREA AND AVOID BREATHING VAPORS.
CONTAIN AND REMOVE WITH INERT ABSORBENT MATERIAL USING NON-SPARKING TOOL S.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
Handling And Storage Precautions: DO NOT STORE IN SUN/ABOVE 100F. STORE LGE
QTYS IN BLDGS DESIGNED FOR STOR OF FLAM/COMBUST LIQS. DO NOT TAKE INTERNALLY.
KEEP OUT OF REACH OF CHILDREN.
Other Precautions: DO NOT WELD/FLAME CUT W/OUT PROPER VENT TO INSURE AREA IS
FREE OF FLAMM VAPS. DO NOT CUT, PUNCTURE/WELD ON/NEAR CONTR. ENTRANCE INTO
CLSD STOR TANKS- USE APPROP NIOSH/MSHA APPRVD RESP/AIRLINE FOR POSS EXPOS TO
SOLV/CHEM FUMES. (SUP DAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 105F,41C
Lower Limits: SEE INGS
Extinguishing Media: USE DRY CHEMICAL OR FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). WATER MAY BE USED TO COOL AND PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard: CLSD CONTRS MAY EXPLODE WHEN EXPOS TO EXTREME
HEAT/FIRE. VAPS CAN FORM EXPLO MIX IN AIR AT ELEVATED TEMPS. MAY DECOMP UNDER
FIRE CNDTNS EMITTING IRRIT (SUP DAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW APPLICABLE
STANDARDS. APPROVED CHEMICAL MECHANICAL FILTER RESPIRATOR DESIGNED TO REMOVE
A COMBINATION OF PARTICULATE AND VAPORS (NIOSH/MSHA TC23C OR EQUIVALE NT).
Ventilation: ALL APPLICABLE AREAS SHOULD BE VENTILATED I/A/W OSHA REGULATION 29
CFR 1910 DURING USE & UNTIL AREA IS FREE OF VAPORS.
Other Protective Equipment: EMERGENCY EYEWASH & DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: USERS OF "L" VERSION OF TO CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). EXPLO HAZ: &/TOX GASES. EFTS OF OVEREXP:
CONTENTS MAY BE HARMFUL/FATAL. OTHER PREC: RAGS/WASTE CONTAINING OIL BASED
PAINT/VA RNISH THAT PRESENT LGE AIR-TO-OIL INTERFACE WILL OXIDIZE & MAY
IGNITE SPONT & SHOULD BE PLACED IN METAL CONTR.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >310F,>154C
Vapor Pres: SEE INGS
Spec Gravity: 1.25-1.33(FP N)
Evaporation Rate & Reference: SLOWER THAN ETHYL ETHER
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 44-47
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES.
Materials To Avoid: CONTACT WITH OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: SOLID TIMBER STAIN (458 LINE), 458312 (VII)
Cage: 85519
Company Name: M A BRUDER & SONS INC
Street: 600 REED RD
PO Box: 600
Zipcode: 19008
Label Required IND: Y
Date Of Label Review: 11/02/1995
Status Code: C
Label Date: 11/02/1995
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: INHALATION: IRRITATION OF
RESPIRATORY TRACT. PROLONGED INHALATION MAY LEAD TO FATIGUE, DROWSINESS,
DIZZINESS AND/OR LIGHT HEADEDNESS, HEADACHE, LACK OF COORDINATION, NAUSEA,
VOMITI NG, CENTRAL NERVOUS SYSTEM DEPRESSION, ANESTHETIC EFFECTS/NARCOSIS.
SKIN: IRRITATION. PROLONGED/REPEATED CONTACT CAN CAUSE DERMATITIS, DEFATTING.
EYE: IRRITATION. PROLONGED/REPEATED CONTACT CAN CAUSE BLURRED VISION,
REDNESS, TEARING, SEVERE IRRITATION. INGESTION: LARGER AMOUNTS MAY CAUSE LUNG
INFLAMMATION & DAMAGE DUE TO ASPIRATION OF MATERIAL INTO LUNGS. CHRONIC:
PROLONGED/REPEATED OVEREXPOSURE T O SOLVENTS MAY CAUSE PERMANENT BRAIN &
CNS DAMAGE.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ARGOSHIELD GAS 15C
CAGE:JO313
CAGE:80382
CAGE:JO313
============= Composition/Information on Ingredients =============
Ingred Name:ARGON
CAS:7440-37-1
RTECS #:CF2300000
Fraction by Wt: 15-95%
OSHA PEL:SIMPLE ASPHYXIANT
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 5-85%
OSHA PEL:5000 PPM
ACGIH TLV:5000 PPM/30000 STEL
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:CARBON DIOXIDE IS MOST
POWERFUL VASODILATOR. INHALING LG CONC CAUSE RAPID CIRCULATORY
INSUFFICIENCY LEADING TO COMA & DEATH. CONC OF 3% TO 5% CARBON
DIOXIDE WHEN INHALED W/ADEQUATE OXYG IN AIR WILL CAUSE INCR IN
RESP RATE. HIGHER CONC WILL CAUSE HDCH, DIZZ, LABORED BRTHG &
EVENTUAL UNCON. EFTS OF EXPOS TO HIGH CONC OF ARGON IN AIR DUE TO
DISPLACEMENT OF OXYG NEC FOR LIFE ARE HDCH, DIZZ , LABORED BRTHG &
EVENTUAL UNCON. OXYG DEFICIENCY DURING PREGNANCY HAS PRDCED
DEVELOPMENTAL ABNORM IN HUMANS & EXPERIMENTAL ANIMALS.OTHER EFTS OF
OXYG DEFICIENCY RSLTG FROM SIMPLE ASPHY MAY INCL:RAPID (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: BRTHG, DIMINISHED MENTAL ALERTNESS,
IMPAIRED MUSCULAR COORD, FAULTY JUDGEMENT, DEPRESS OF ALL
SENSATIONS, EMOTIONAL INSTABILITY & FATG. ASPHYX PROGRESS NAUS,
VOMIT, PROSTRATION, & LOSS OF CO NSCIOUSNESS MAY RSLT EVENTUALLY
LEADING TO CONVL, COMA, & DEATH. TOX INFO:OXYG DEFICIENCY DURING
PREGNANCY HAS PRODUCED DEVELOPMENT ABNORMALITIES IN HUMANS AND
EXPERIMENTAL ANIMALS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMED . EYES:IMMED FLUSH W/POTABLE WATER FOR
MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD . SKIN:FLUSH
W/COPIOUS AMTS OF WATER. CALL MD . INHAL:PROMPT MED ATTN IS MA
NDATORY IN ALL CASES OF OVEREXP. RESCUEPERS SHOULD BE EQUIPPED
W/NIOSH/MSHA APPRVD SCBA. VICTIMS SHOULD BE ASSISTED TO UNCONTAMD
AREA & INHALE FRESH AIR. QUICK REMOVAL FROM CONTAMD AREA IS MOST
IMPORT ANT. UNCON PERSONS SHOULD BE MOVED TO UNCONTAMD AREA. IF
THEY ARE NOT BRTHG, ADMIN ARTF RESUSCITATION. FURTHER TREATMENT
SHOULD BY SYMPTOMATIC AND SUPPORTIVE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:USE EXTINGUISHING MEDIA SUITABLE FOR COMBUSTIBLE
MATLS INVOLVED IN FIRE. USE WATER SPRAY TO COOL FIRE EXPOS CNTNRS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE. NONFLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC ALL PERS FROM AFFECTED AREA. USE APPROP
PROT EQUIP. IF LEAK IS IN USER'S EQUIP, BE CERTAIN TO PURGE PIPING
W/INERT GAS PRIOR TO ATTEMPTING REPAIRS. IF LEAK IS IN CNTNR OF
MANUFACTURE LOCATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN WELL-VENTILATED AREAS.
VALVE PROT CAPS MUST REMAIN IN PLACE UNLESS CNTNR IS SECURED
W/VALVE OUTLET PIPED TO USE POINT.
Other Precautions:DO NOT DRAG, SLIDE/ROLL CYLS. USE SUITABLE HAND TRUCK
FOR CYL MOVEMENT. USE PRESS REDUCING REGULATOR WHEN CONNECTING CYL
TO LOWER PRESS (<3000 PSIG) PIPING/SYS. DO NOT HEAT CYL BY ANY
MEANS TO INCR DI SCHARGE RATE OF PROD FROM CYL. USE CHECK
VALVE/TRAP IN DISCHARGE LINE TO PVNT HAZ BACK FLOW INTO SYS .
PROTECT (SUP DAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA APPRVD SUPPLIED RESP W/FULL
FACEPIECE EQUIPPED W/ESCAPE BOTTLE OR NIOSH/MSHA APPRVD SCBA SHOULD
BE AVAIL FOR EMER USE. OPERATE EQUIP IN POSITIVE PRESSURE DEMAND
MODE.
Ventilation:USE LOCAL EXHAUST AND GENERAL VENT TO MAINTAIN MINIMUM19.5%
OXYG LEV & <9.5% CARBON DIOXIDE LEV IN AMBIENT AIR.
Other Protective Equipment:SAFETY SHOES. ANSI APPRVD EMERGENCY EYE WASH
& DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PREC: CYL FROM PHYSICAL DMG. STORE IN COOL, DRY, WELL-VENTILATED
AREAS AWAY FROM HEAVILY TRAFFICKED AREAS & EMER EXISTS. DO NOT
ALLOW TEMP WHERE CYLS ARE STORED TO EXCEED 125(52C). CYL SHOULD BE
STORED UPRIGHT & FIRMLY SECURED TO PVNT FALLING/BEING KNOCKED OVER.
FULL & EMPTY CYLS SHOULD BE (OTHER INFO)
================== Physical/Chemical Properties ==================
Spec Gravity:1.39 (AIR =1)
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:SLIGHT
Appearance and Odor:ODORLESS; COLORLESS GAS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP MUST BE I/A/W FED, ST & LOC REGS . DO NOT
ATTEMPT TO DISPOSE OF RESIDUAL WASTE/UNUSED QTYS. RETURN IN
SHIPPING CNTNR PROPERLY LBLD, W/ANY VALVE OUTLET PLUGS/CAPS SECURED
& VALVE PROT CAP IN PLACE TO MFR GASES/AUTHORIZED FOR PROPER DISP.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:O-DIANISIDINE DIHYDROCHLORIDE, D3252
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:O-DIANISIDINE DIHYDROCHLORIDE
CAS:20325-40-0
RTECS #:DD1050000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE EFFECTS: HARMFUL IF SWALLOWED,
INHALED OR ABSORBED THROUGH SKIN. CAUSES EYE AND SKIN IRRITATION.
MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT. CAUSES SNEEZING. DO NOT I NHALE. CHRONIC EFFECTS:
CARCINOGEN. MAY ALTER GENETIC MATERIAL. TARGET ORGAN: BLADDER.
ALSO, SEE TOXICOLOGICAL INFORMATION.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES WITH COPIOUS
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. SKIN: IN CASE OF CONTACT,
IMMEDIATELY FLUSH SKIN WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST
15 M INUTES WHILE REMOVING CONTAMINATED CLOTHING AND SHOES.
INHALATION: IF INHALED, REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
INGESTION: IF SWALLOWED, WASH OUT MOUTH WITH WATER PROVIDED PERSON
IS CONSCIOUS. CALL A PHYSICIAN. DISCARD CONTAMINATED CLOTHING AND
SHOES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY. CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR NIOSH APPROVED
SELF-CONTIANED BREATHING APPARATUS, RUBBER BOOTS AND HEAVY RUBBER
UP, PLACE IN A BAG AND HOLD FOR WASTE DISPOSAL. VENTILATE AREA AND
WASH SPILL SITE AFTER MATERIAL PICKUP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. STORE IN A COOL,
DRY PLACE.
Other Precautions:DO NOT BREATHE DUST. AVOID ALL CONTACT. AVOID
PROLONGED OR REPEATED EXPOSURE. WASH THOROUGHLY AFTER HANDLING.
CARCINOGEN. IRRITANT. STERNUTATOR. MUTAGEN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMCIAL FUME HOOD.
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
OTHER PROTECTIVE CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:=286.C, 546.8F
M.P/F.P Text:(DEC)
Appearance and Odor:SOLID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE, NITROGEN OXIDES, HYDROGEN CHLORIDE GAS.
=================== Toxicological Information===================
Toxicological Information:RTECS #: DD1050000, BENZIDINE,
3,3,'-DIMETHOXY-, DIHYDROCHLORIDE. TARGET ORGAN DATA: SENSE ORGANS
AND SPECIAL SENSES (TUMORS). LIVER (TUMORS). TUMORIGENIC EFFECTS
(TESTICULAR TUMORS). TUMORIGENIC EFFE CTS (UTERINE TUMORS).
TUMORIGENIC (CARCINOGENIC BY RTECS CRITERIA). TUMORIGENIC
(EQUIVOCAL TUMORIGENIC AGENT BY RTECS CRITERIA). ONLY SELECTED
REGISTRY OF TOXIC EFFECTS OF CHEMICAL SUBSTANCES (RTECS) DATA IS
PRESENTED HERE. SEE ACTUAL ENTRY IN RTECS FOR COMPLETE INFORMATION.
===================== Ecological Information =====================
Ecological:DATA NOT YET AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:CONTACT SIGMA CHEMICAL COMPANY FOR TRANSPORTATION
INFORMATION.
===================== Regulatory Information =====================
SARA Title III Information:THIS PRODUCT IS SUBJECT TO SARA SECTION 313
REPORTING REQUIREMENTS.
Federal Regulatory Information:EUROPEAN INFORMATION - EC INDEX NO:
612-037-00-5. TOXIC. R 22 HARMFUL IF SWALLOWED. R 45 MAY CAUSE
CANCER. S 45 IN CASE OF ACCIDENT OR IF YOU FEEL UNWELL, SEEK
MEDICAL ADVICE IMMEDIATELY (SHOW THE LAB EL WHERE POSSIBLE). S 53
AVOID EXPOSURE - OBTAIN SPECIAL INSTRUCTIONS BEFORE USE.
State Regulatory Information:CALIFORNIA PROPOSITION 65: THIS PRODUCT IS
OR CONTAINS CHEMICAL(S) KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
======================= Other Information =======================
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-388-4564
Product ID: SILVER COPPER NICKEL ZINC BRAZING ALLOYS
Cage: 91874
=======================================================
Contractor Summary
=======================================================
Cage: 91874
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Specification Number: UNKNOWN
Unit of Issue: CL
Quantitative Expression: 00000000016OZ
UI Container Qty: 0
Type of Container: COIL, WIRE
=======================================================
Ingredients
=======================================================
Cas: 7440-50-8
RTECS #: GL5325000
% low Wt: 19.
% high Wt: 60.
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 0.1MG/M3 FUME/1 DUST
ACGIH TLV: 0.2 MG/M3 FUME; 9596
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 7440-02-0
RTECS #: QR5950000
% low Wt: .5
% high Wt: 5.
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 1 MG/M3
ACGIH TLV: 1 MG/M3; 9596
-----------------------------
Cas: 7440-22-4
RTECS #: VW3500000
% low Wt: 1.
% high Wt: 55.
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 0.01 MG/M3
ACGIH TLV: 0.1 MG/M3; 9596
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 7440-66-6
RTECS #: ZG8600000
% low Wt: 4.
% high Wt: 44.
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: UNKNOWN
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: INHALATION OF THE COMPONENTS OF THESE PRODUCTS IS NOT
KNOWN TO PRESENT A SIGNIFICANT RISK TO HEALTH WHEN USED ACCORDING TO
INSTRUCTIONS & WITH APPROPRIATE PROTECTIVE MEASURES. INHALATION OF
COMPONENET ELEMENTS HAS BEEN REPORTED TO CAUSE ONE OR MORE OF THE FOLLOWING
SYMPTOMS ANDEFFECTS UPON EXCESSIVELY HIGH OR PROLONGED EXPOSURE. (SEE
OVEREXPOSURE)
Explanation Of Carcinogenicity: NICKEL IS CLASSIFIED AS A POTENTIAL HUMAN
CARCINOGEN BY: IARC (GROUP 2B); NTP (GROUP 2B). NONE OF THE OTHER COMPONENTS
OF THESE PRODUCTS ARE CLASSIFIED AS POTENTIAL OR DEMONSTRATED CARCINOGENS BY
IARC , NTP OR OSHA.
Signs And Symptions Of Overexposure: COPPER: MAY CAUSE RESPIRATORY TRACT
IRRITATION, FEVER, MUSCLE ACHE, CHILLS, COUGH, WEAKNESS & A METALLIC
TASTE. MAY DAMAGE THE LIVER, KIDNEY, SLEEN, PANCREAS & BRAIN. NICKEL:
MAY CAUSE HEADACHE, N AUSEA, VERTIGO, ASTHMA & PULMONARY EDEMA. MAY
INCREASE THE RISK OF CANCER TO THE NASOPHARYNX, LUNGS, PROSTATE & KIDNEY.
SILVER: MAY PRODUCE ARGYRIA, A PERMANENT BLUE-GRAY DISCOLORATION OF THE
SKIN, EYES, MUCOUS MEMBRANES & RESPIRATORY TRACT. ZINC: MAY CAUSE
RESPIRATORY TRACT IRRITATION & "METAL FUME FEVER" A METALLIC TASTE,
COUGH, DRY THROAT, CHILLS, FEVER, TIGHTNESS OF CHEST, HEADACHE, NAUSEA,
SHORTNESS OF BREATH, VOMITING & FATIGUE.
Medical Cond Aggravated By Exposure: PRE-EXIST PULMONARY DISEASES (E.G.
BRONCHITIS, ASTHMA) MAY BE AGGRAVATED BY INHALATION EXPOSURE, PARTICULARY AS
FUME. MAY AGGRAVATE THE LIVER, KIDNEYS, GASTROINTESTINAL SYSTEM,
MUSCULOSKELETAL SYSTEM.
First Aid: INHALATION-REMOVE SUBJECT FROM AREA, ADMINISTER OXYGEN & SEEK
MEDICAL ATTENTION.KEEP THE SUBJECT WARM & AT REST. PERFORM ARTIFICIAL
RESPIRATION IF BREATHING HAS STOPPED. SKIN-REMOVE CONTAMINATED CLOTH ING.
WASH AFFECTED AREA WITH LARGE QUANTITIES OF WATER FOR 5 MIN. SEEK MEDICAL
ASSISTANCE IF NEEDED. EYE-FLUSH AFFECTED AREA WITH WATER FOR 15 MIN. SEEK
MEDICAL ASSISTANCE IF NEEDED. IF CONSCIOUS, IND UCE VOMITING. IF CONSCIOUS OR
CONVULSIVE, SEEK IMMEDIATE MEDICAL ASSISTANCE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: IF A FINELY DIVIDED FORM OF PRODUCT IS SPILLED,
CLEANUP SPILLAGE SO AS TO MINIMIZE DISPERSION OF DUST. WET SWEEPING OR
VACUUMING USING HEPA FILTRATION ARE RECOMMENDED.
Waste Disposal Methods: CONSULT THE MANUFACTURER FOR DISPOSITION OF UNUSED OR
UNUSABLE PRODUCT.
Handling And Storage Precautions: DO NOT STORE IN PROXIMITY TO INCOMPATIBLE
MATERIALS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: USE DRY CHEMICAL. DO NOT USE WATER.
Fire Fighting Procedures: IF FIGHTING A FIRE IN WHICH THESE PRODUCT ARE
PRESENT, WEAR A SELF-CONTAINED BREATHING APPARATUS WITH FULL FACEPIECE
OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard: THESE PRODUCTS MAY REACT VIGOROUSLY OR IGNITE
WHEN EXPOSED TO INCOMPATIBLE MATERIALS. IF PRESENT IN A FIRE OR EXPLOSION,
THEY WILL EMIT FUMES OF THE CONSTITUENT METALS AND/OR METAL OXIDES.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF EXPOSURE LEVEL EXCEEDS OSHA PEL WEAR NIOSH/MSHA
APPROVED RESPIRATOR HAVING CONFIGURATION (CLASS,TYPE OF FACPIECE,FILTER
MEDIA,ASSIGNED PROTECTION FACTOR,ETC) APPROPRIATE TO CONCENTRATION OFTHE CONT
AMINANTS GENERATED. SELECTION GUIDANCE/PROPER USE SEE ANSI Z99.2-1992.
Ventilation: USE APPROPIATE VENTILATION (E.G. DILUTION, LOCAL EXHAUST) ADEQUATE
TO MAINTAIN CONCENTRATIONS OF ALL COMPONENTS & THEIR BY PRODUCTS.
PREVENT SKIN INJURIES FROM THE HAZARDS OF BRAZING AND FOR PROLONGED CONTACT
WITH FINLEY DIVIDED FORMS OF PRODUCT.
Work Hygienic Practices: TO AVOID INGESTION, WASH HANDS AND FACE BEFORE EATING,
DRINKING OR USING COSMETICS OR TABACCO.
SIDE SHIELDS AND FILTER LENSES (SHADE #3 OR #4) ARE RECOMMENDED.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
Melt/Freeze Pt: >660.C, ######F
Solubility in Water: INSOLUBLE
Appearance and Odor: NO ODOR,WHITE TO LIGHT YELLOW
METALS,FORM:WIRE,ROD,STRIP,POWDER,GRAIN,PREF SHAP
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES NITROBENZENE; SELENINYL BROM
Stability Condition To Avoid: SILVER AND COPPER CAN FORM UNSTABLE ACETYLIDES
UPON CONTACT WITH ACETYLENE GAS.
Materials To Avoid: SE; TE; MG; CHLORATES; NH3; HNO3; AZIDES, ETHANOL, ETHYLENE
IMINE; CLF3; INORGANIC AND ORGANIC PEROXIDES; PEROXYFORMIC ACID; CHLORINE AND
FLUORINE; PERMONOSULFURIC ACID; CRO3; MN AND CA CHLORIDES; CS2; HYDRAZINE
MONONITRATE
Hazardous Decomposition Products: HEATING TO ELEVATED TEMPS MAY LIBERATE
METAL/METAL OXIDE FUME.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
Toxicological Information: GENERIC/REPRODUCTIVE EFFECTS; NICKEL HAS PRODUCED
FETOTOXIC AND TERATOGENIC EFFECTS IN ANIMAL STUDIES AND MUTAGENIC RESPONSES
IN MAMMALIAN CELL CULTURES.
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
Transport Information: SHIPMENT NOT CONTROLLED BY USDOT/IATA/ICAO/IMO
REGULATIONS.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: COPPER, NICKEL, SILVER AND ZINC.
State Regulatory Information: WARNING: THESES PRODUCTS CONTAIN A CHEMICAL KNOWN
TO THE STATE OF CALIFORNIA TO CAUSE CANCER.
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 145716
Product ID: SILVER COPPER NICKEL ZINC BRAZING ALLOYS
Review Date: 07/09/1999
Multiple KIT Number: 0
Unit Of Issue: CL
Container QTY: 0
Type Of Container: COIL, WIRE
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: SILVER COPPER NICKEL ZINC BRAZING ALLOYS
Cage: 91874
Company Name: LUCAS-MILHAUPT INC A HANDY & HARMAN CO
Street: 5656 SOUTH PENNSYLVANIA AVENUE
Zipcode: 53110
Label Required IND: Y
Date Of Label Review: 07/09/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: INHALATION OF THE COMPONENTS OF THESE PRODUCTS IS NOT
KNOWN TO PRESENT A SIGNIFICANT RISK TO HEALTH WHEN USED ACCORDING TO
INSTRUCTIONS & WITH APPROPRIATE PROTECTIVE MEASURES. INHALATION OF
COMPONENET ELEMENTS HAS BEEN REPORTED TO CAUSE ONEOR MORE OF THE FOLLOWING
SYMPTOMS ANDEFFECTS UPON EXCESSIVELY HIGH OR PROLONGED EXPOSURE. (SEE
OVEREXPOSURE)
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WF-D (GUIDE SHOE)
Preparer's Name:TERRY HELLER
CAGE:58436
CAGE:58436
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:10MG/CUM(OXIDE FUME)
ACGIH TLV:10MG/CUM(OXIDE FUME)
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
Ingred Name:GRAPHITE, SYNTHETIC
CAS:7440-44-0
RTECS #:FF5250100
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Other REC Limits:5MG/CUM(RESP.DUST)
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
OSHA PEL:10 MG ZNO/M3
ACGIH TLV:10 MG ZNO/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:OPERATIONS SUCH AS
ABRADING,MELTING,WELDING,CUTTING OR PROCESSING IN ANY OTHER FASHION
MAY PRODUCE POTENTIALLY HAZARDOUS DUST OR FUMES WHICH CAN BE
INHALED,SWALLOWED,OR COME IN CONTACT WITH THE SKIN O R EYES. DUST
OR FUME MAY CAUSE IRRITATION TO THE EYES,NOSE OR THROAT; -CONTINUES
IN SUPPLEMENTAL SAFETY & HEALTH DATA-
Explanation of Carcinogenicity:NICKEL IS A CARCINOGEN AND CERTAIN
COMPOUNDS OF CHROMIUM AND COBALT HAVE BEEN IDENTIFIED AS SUSPECT
HUMAN CARCINOGENS.
Effects of Overexposure:SEE HEALTH HAZARDS AND MEDICAL CONDITIONS
AGGRAVATED BY EXPOSURE.
Medical Cond Aggravated by Exposure:OVEREXPOSURE SYMPTOMS MAY BE
AGGRAVATED FOR SENSITIVE INDIVIDUALS WITH RESP.CONDITION (SUCH AS
EMPHYSEMA). PERSON WITH LT SKIN,SENSITIVE SKIN OR LG AMTS OF BODY
HAIR MAY EXPERIENCE SKIN DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER.SEEK MEDICAL ATTENTION;SKIN:WASH WITH
SOAP & WATER;INHALATION:REMOVE TO FRESH AIR.IF NOT BREATHING GIVE
CPR.SEEK MEDICAL ATTENTION;INGESTION:SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Unusual Fire/Explosion Hazard:DUST HAZARDS EXIST UNDER FAVORING
CONDITIONS OF SMALL PARTICLE SIZE. DISPERSION IN AIR AND STRONG
IGNITION SOURCE MAY RESULT IN AN EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP AND PLACE IN APPROPRIATE DISPOSAL
CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL PROCEDURE REQUIRED.
Other Precautions:REMOVE TRACES OF MATERIAL DUST IF
SOLDERING,WELDING,BRAZING,CUTTING OR OTHER PROCESS INVOLVING
IGNITION SOURCES TO PREVENT A FIRE HAZARD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CASE OF DUST CONDITIONS,USE NIOSH APPROVED
RESPIRATOR FOR METAL DUST.
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:STANDARD PRACTICE
Supplemental Safety and Health
HEALTH HAZARDS,CONT'D:LEAVES A METALLIC TASTE IN THE MOUTH;RESULTS IN
METAL FUME FEVER (FLU-LIKE SYMPTOMS)>
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:1100-2500F
Spec Gravity:7.8
Solubility in Water:NOT SOLUBLE
Appearance and Odor:SOLID METAL OBJECT. ANTI-RUST COATING HAS ODOR OF
KEROSENE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS,GASES OR STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:METAL FUMES IF HEATED. ANTI-RUST
COATING IS COMBUSTIBLE AND WILL PRODUCE OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW FEDERAL,STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-P-24441/6,FORM 155,DARK GRAY,COMP A
CAGE:HO103
CAGE:HO103
CAGE:29430
============= Composition/Information on Ingredients =============
Ingred Name:AMIDOAMINE REACTANT
Fraction by Wt: <5.0%
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <5.0%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 35.0%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:POLYAMIDE BASED RESIN
===================== Hazards Identification =====================
Effects of Overexposure:EYE DAMAGE/PAIN.VAPORS:RESP TRACT
IRRIT,DIZZY,NAUSEA,LOSS OF CONSCIOUSNESS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER 15 MIN,GET MEDICAL ATTEN.SKIN:WASH WITH
SOAP AND WATER.INHALATION:REMOVE FROM EXPOSURE.GIVE ARTIF RESP IF
NEEDED,GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:99F/37C(TCC/PM)
Lower Limits:1.4
Upper Limits:11.2
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,FOAM,WATER FOG.
Fire Fighting Procedures:SELF-CONT BREATH APP,EATER FOG TO COOL EXPOSED
CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES.VENTILATE
AREA,AVOID BREATHING OF VAPORS AND PERSONAL CONTACT.REMOVE WITH
INERT ABSORBENT AND NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F/48C,KEEP AWAY
FROM HEAT,SPARKS AND OPEN FLAMES.GROUND CONTAINER WHEN
POURING,AVOID FREE FALL IN EXCESS OF A FEW INCHES.
Other Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:SPRAY BOOTH/LOCAL/MECHANICAL WITH EXPLOSION PROOF MOTORS
Other Protective Equipment:PROTECTIVE CLOTHING TO PREVENT SKIN CONTACT.
Supplemental Safety and Health
PART A OF A 2 PART KIT.CONTAINER SIZE: 1 GAL
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:243F/117C
Vapor Pres:4.2
Vapor Density:2.6
Spec Gravity:1.25
Evaporation Rate & Reference:0.43
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NORMAL FOR A PAINT OR COATING TYPE PRODUCT
Percent Volatiles by Volume:53
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:AMMONIA COMPOUNDS,NITROTEN
OXIDES,CO*2,CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN CHEMICAL DISPOSAL AREA OR IN A MANNER
THAT COMPLIES WITH LOCAL,STATE AND FEDERAL REGULATIONS. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:THERMOFLEX FELT REFRACTORY CERAMIC FIBER PRODUCTS
CAGE:0UHC8
CAGE:0UHC8
============= Composition/Information on Ingredients =============
Ingred Name:REFRACTORIES FIBERS, ALUMINOSILICATE
CAS:142844-00-6
Fraction by Wt: 89-98%
Ingred Name:PHENOLIC RESIN, PHENOL FORMALDEHYDE RESIN, PHENOL POLYMER W
FORMALDEHYDE, PHENOL-FORMALDEHYDE COPOLYMER *95-4*
CAS:9003-35-4
Fraction by Wt: 2-11%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: THROAT, NOSE & RESPIRATORY
TRACT IRRITATION. INGESTION: IRRITATION TO GI TRACT. SKIN/EYS:
PHYSICAL IRRITATION.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, INFLAMMATION, RASH, SORENESS.
Medical Cond Aggravated by Exposure:LUNG, RESPIRATORY & CARDIAC
CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. DON'T RUB.
SKIN: WASH W/SOAP & WATER. CREAM LOTION AFTER WASHING MAY BE
HELPFUL. INGESTION: DON'T INDUCE VOMITING, DRINK PLENTY OF WATER.
INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING AREAS.
Fire Fighting Procedures:WEAR FULL BUNKER GEAR INCLUDING POSITIVE
PRESSURE SCBA.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CREATING AIRBORNE DUST. VACUUM ONLY
W/HEPA FILTERED EQUIPMENT. IF SWEEPING IS NECESSARY, USE A DUST
SUPPRESSANT & PLACE MATERIAL IN CLOSED CONTAINERS. DON'T USE
RESPIRATOR. (SUPP)
======================Handling and Storage ======================
Handling and Storage Precautions:LIMIT USE OF POWER TOOLS IN
CONJUNCTION W/LOCAL EXHAUST. USE HAND TOOLS, WHENEVER POSSIBLE.
FREQUENTLY CLEAN AREA W/HEPA FILTERED VACUUM/WET SWEEPING.
Other Precautions:STORE IN ORIGINAL FACTORY CONTAINER IN A DRY AREA.
KEEP CONTAINER CLOSED WHEN NOT IN USE. GOOD VENTILATION SHOULD BE
PROVIDED DURING INITIAL HEATING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN IT'S IMPOSSIBLE/FEASIBLE TO REDUCE AIRBORNE
FIBERS & DUST LEVELS BELOW EXPOSURE LIMITS THROUGH ENGINERING
CONTROLS, EMPLOYEES ARE ENCOURAGED TO USE GOOD WORK PRACTICES
W/NIOSH/MSHA APPROVED RESPI RATORY PROTECTION.
Ventilation:USE ENGINEERING CONTROLS TO REDUCE AIRBORNE FIBER
CONCENTRATIONS TO THE LOWEST ATTAINABLE LEVEL.
Other Protective Equipment:FULL BODY CLOTHING, HAT.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. RINSE WASHER AFTER USE.
Supplemental Safety and Health
IF TAKING WORK CLOTHING HOME, IT'S RECOMMENDED YOU VACUUM YOUR CLOTHES
W/HEPA FILTERED VACUUM BEFORE LEAVING WORK AREA. SPILL PROCEDURES
CONT'D: AVOID CLEAN UP PROCEDURE THAT COULD RESULT IN WATER POL
LUTION.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>3200F
Spec Gravity:2.5-2.7
Solubility in Water:INSOLUBLE
Appearance and Odor:FELTED/WETTED BLANKET W/SLIGHT PHENOLIC ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID, PHOSPHORIC ACID, STRONG ALKALIES.
Hazardous Decomposition Products:CO2, CO, TRACES OF AMMONIA,
FORMALDEHYDE & PHENOL DURING INITIAL HEATING.
==================== Disposal Considerations ====================
Waste Disposal Methods:TO PREVENT MATERIALS BECOMING AIRBORNE, A
COVERED CONTAINER/PLASTIC BAGGING IS RECOMMENDED. DISPOSE IN A
LANDFILL IAW/FEDERAL, STATE & LOCAL REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:K-1513AMC
CAGE:2Y081
CAGE:2Y081
============= Composition/Information on Ingredients =============
Ingred Name:ACRYLIC MONOMER; (ACRYLAMIDE MONOMER)
Fraction by Wt: 0.2%
Ingred Name:PETROLEUM DISTILLATE
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CONTACT CAN CAUSE IRRITATION,
REDNESS, SEVERE OR PERMANENT DAMAGE. SKIN: PROLONGED OR REPEATED
CONTACT CAN CAUSE IRRITATION. INHAL: MIST MAY IRRITATE NASAL AND
RESPIRATORY PASSAGES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR A MINIMUM OF 15 MINUTES. GET MEDICAL
HELP IF IRRITATION PERSISTS. INHAL: REMOVE TO FRESH AIR. IF
NECESSARY, GIVE OXYGEN, ARTIFICIAL RESPIRATION. INGEST: GIVE LARGE
QUANTITIES O F WATER. GET MEDICAL ASSISTANCE. SKIN: FLUSH W/COPIOUS
AMOUNTS OF WATER. CALL MD .
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:140F,60C
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . COOL EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON SOLID ABSORBENT OR WASH DOWN WITH
WATER. REMOVE ALL SOURCES OF IGNITION AND VENTILATE AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT MODERATE TEMPERATURES. KEEP
CONTAINER CLOSED WHEN NOT IN USE. KEEP AWAY FROM HEAT AND OPEN
FLAMES.
Other Precautions:KEEP OUT OF THE REACH OF CHILDREN. RETURN EMPTY DRUMS
TO A LICENSED RECONDITIONING SERVICE. AVOID PROLONGED OR REPEATED
BREATHING OF VAPORS OR CONTACT WITH THE SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR PRODUCT
MISTS.
Ventilation:RECOMMENDED.
Other Protective Equipment:EYE WASH STATION.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1-1.03
Appearance and Odor:MILKY, WHITE LIQUID - SLIGHT HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY DISSOLVE SOME PLASTICS AND RUBBER.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NON-CASE
CAGE:28888
Contract Num:SP0450-99-M-NC02
CAGE:28888
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE
CAS:1310-73-2
RTECS #:WB4900000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH STEL:C2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SILICATE
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYES, SKIN, RESPIRATORY
SYSTEM (NIOSH). ACUTE HEALTH HAZARD - EYES: IRRITATION. SKIN:
IRRITATION. INHALATION: DOES NOT APPLY. INGESTION: MAY IRRITATE
GASTROINTESTINAL TRACT. CHRONIC HE ALTH HAZARD - UNKNOWN.
Explanation of Carcinogenicity:COMPONENTS OF THIS PRODUCT ARE NOT
LISTED AS CARCINOGEN.BY IARC, NTP, OR OSHA.
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:NONE LISTED
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE VICTIM TO FRESH AIR. CALL A PHYSICIAN. EYE
CONTACT: IMMEDIATELY FLUSH WITH LARGE QUANTITIES OF WATER FOR AT
LEAST 15 MINUTES AND CALL A PHYSICIAN. SKIN CONTACT: WASH WITH SOAP
AND WATER. INGESTION: IF SWALLOWED, DO NOT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Extinguishing Media:NON-FLAMMABLE
Fire Fighting Procedures:DOES NOT APPLY
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL, STOP SOURCE OF LEAK, PUNP
SPILLED MATERIAL INTO SALVAGE CONTAINER. SOAK UP REMAINING MATERIAL
WITH ABSORBENT SUCH AS SAND OR CLAY. PREVENT PRODUCT FROM ENTERING
POTABLE OR NATURAL WATER SYSTEM.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN NORMAL OIL STORAGE AREA IN
TIGHTLY CLOSED CONTAINERS AND AWAY FROM DIRECT HEAT SOURCE AND
STRONG OXIDIZING AGENTS. AVOID CONTACT WITH SKIN, EYES, AND
CLOTHING. DO NOT SWALLOW. WASH THOROUGHLY AFTER HANDLING. KEEP
AWAY FROM FEED PRODUCTS. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Other Precautions:DO NOT PRESSURIZE, CUT, WELD, BRAZE, DRILL, GRIND OR
HEAT EMPTY CONTAINERS, SOME RESIDUE MAY BE PRESENT. AVOID BREATHING
OIL MIST. DO NOT ADD SUPPLEMENTAL NITRITES. FOR INDUSTRIAL USE
ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:GENERAL IS ADEQUATE.
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B1
Spec Gravity:>1.00
Solubility in Water:SLIGHT
Appearance and Odor:BROWN PASTE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
LOCAL, STATE, AND FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:12-000, SILVER
CAGE:6A753
Contract Num:SP0490-97-M-AK85
CAGE:6A753
============= Composition/Information on Ingredients =============
Ingred Name:SILVER
CAS:7440-22-4
RTECS #:VW3500000
> Wt:99.9
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHRONIC EXPOSURE TO SILVER MAY PRODUCE
ARGYRIA, A PERMANENT BLUE-GRAY DISCOLORATION OF THE SKIN, EYES,
MUCOUS MEMBRANES, AND THE RESPIRATORY TRACT. SKIN: CONTACT WITHTHIS
PRODUCT IN FINELY-DIVIDED FOR MS MAY CAUSE ARGYRIA. EYE: EXPOSURE
TO THI SPRODUCT IN FINELY-DIVIDED FORMS MAY CAUSE IRRITATION AND/OR
ARGYRIA. INGESTION: THIS PRODUCT IN FINELY-DIVIDED FORMS MAY CAUSE
NAUSEA, VOMITING, AND GASTROI NTESTINAL IRRITATION.
Explanation of Carcinogenicity:SILVER IS NOT CLASSIFIED AS A POTENTIAL
OR DEMONSTRATED HUMAN CARCINOGEN.
Effects of Overexposure:CHRONIC: A PERMANENT BLUE-GRAY DISCOLORATION OF
THE SKIN, EYES, MUCOUS MEMBRANES, AND THE RESPIRATORY TRACT. SKIN:
ARGYRIA. EYE: IRRITATION AND/OR ARGYRIA. INGESTION: NAUSEA,
VOMITING, AND GASTROINTES TINAL IRRITATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING PULMONARY DISEASES
(E.G., BRONCHITIS, ASTHMA) MAY BE AGGRAVATED BY INHALATION
EXPOSURE, PARTICULARLY AS FUME.
======================= First Aid Measures =======================
First Aid:INHALTION: IF SIGNS AND SYMPTOMS OF TOXICITY ARE OBSERVED,
REMOVE SUBJECT FROM AREA, ADMINISTER OXYGEN, AND SEEK MEDICAL
ATTENTION. KEEP THE SUBJECT WARM AND AT REST. PERFORM ARTIFICIAL
RESPIRATION IF BREATHING IS STOPPED. SKIN: REMOVE CONTAMINATED
CLOTHING. WASH AFFECTED AREA WITH LARGE QUANTITIES OF WATER FOR AT
LEAST FIVE MINUTES. SEEK MEDICAL ATTENTION IF NECESSARY. EYE: FLUSH
AFFECTED AREAS W ITH WATER FOR AT LEAST 15 MINUTES. SEEK MEDICAL
ASSISTANCE IF NECESSARY. INGESTION: IF SUBJECT IS CONSCIIOUS,
INDUCE VOMITING. IF UNCONSCIOUS OR CONVULSIVE, SEEK IMMEDIATE
MEDICAL ASSISTANCE.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE DRY POWDER. DO NOT USE WATER.
Fire Fighting Procedures:IF FIGHTING A FIRE IN WHICH THIS PRODUCT IS
PRESENT, WEAR A SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE PRESSURE
MODE.
Unusual Fire/Explosion Hazard:IN FINELY-DIVIDED FORM, THIS PRODUCT MAY
IGNITE WHEN EXPOSED TO FLAME OR BY REACTION WITH INCOMPATIBLE
MATERIALS(SEE REACTIVITY). IF PRESENT IN A FIRE OR EXPLOSION, IT
MAY CREATE POTENTIALLY TOXIC CON CENTRATIONS OF METAL OR METAL
OXIDE FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:IF A FINELY-DIVIDED FORM OF PRODUCT IS
SPILLED, CLEAN UP SPILLED MATERIAL SO AS TO MINIMIZE DISPERSION OF
DUST. WET SWEEPING OR VACUUMING USING HEPA FILTRATION ARE
RECOMMENDED.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE IN PROXIMITY TO
INCOMPATIBLE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF AN EXPOSURE LEVEL EXCEEEDS AN OSHA PEL OR
OTHER APPLICABLE STANDARD, USE A NIOSH-APPROVED RESPIRATOR HAVING A
CONFIGURATION (CLASS, TYPE OR FACEPIECE, FILTER MEDIA, ASSIGNED
PROTECTION FACTOR, ETC) APPROPRIATE TO THE CONCENTRATION OF THE
CONTAMINANTS CREATED. FOR GUIDANCE ON SELECTION AND USE OF
RESPIRATORY PROTECTION, CONSULT AMERICAN NATIONAL (SUPP)
Ventilation:USE MECHANICAL (LOCAL EXHAUST OR GENERAL) ADEQUATE TO
MAINTAIN CONCENTRATIONS OF ALL COMPONENTS AND DECOMPOSITION
PRODUCTS WITHIN PELS.
LENSES
Work Hygienic Practices:TO MINIMIZE THE POSSIBILITY OF INGESTION WASH
HANDS AND FACE BEFORE EATING, DRINKING, APPLYING COSMETICS, OR
USING TOBACCO.
Supplemental Safety and Health
CONT'D FROM RESPIRATORY PROTECTION: STANDARD Z88.2 (ANSI, NEW YORK, NY
10036 USA).
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:=2212.2C, 4014.F
Melt/Freeze Pt:=962.C, ######F
Spec Gravity:10.5
Solubility in Water:INSOLUBLE
Appearance and Odor:ODORLESS SILVER-WHITE METAL IN FORM OF WIRE, ROD,
TUBING, SHEET, GRAIN, ANODES,
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AMMONIA, NITRIC ACID, ETHYLENE IMINE, CHLORINE TRIFLUORIDE, H2SO4,
INORGANIC AND ORGANIC PEROXIDES, PEROXYFORMIC ACID, BROMOAZIDE,
OXALIC ACID, TARTARIC ACID, 1-BROMO-2-PROPYNE, PERMONOSULFURIC
ACID.
Stability Condition to Avoid:STABLE AT ROOM TEMPERATURE. SILVER CAN
FORM AN UNSTABLE ACETYLIDE UPON CONTACT WITH ACETYLENE GAS.
Hazardous Decomposition Products:HEALTING TO ELEVATED TEMPERATURES MAY
VOLATILIZE SILVER AS FUME.
==================== Disposal Considerations ====================
Waste Disposal Methods:RETURN TO MANUFACTURER FOR RECLAIM.
=================== MSDS Transport Information ===================
Transport Information:SHIPMENT NOT CONTROLLED BY USDOT/ICAO/IMO
REGULATIONS.
===================== Regulatory Information =====================
SARA Title III Information:RQ = 1000 LBS. HAZARD CLASSES: CHRONIC
HEALTH HAZARD, FIRE HAZARD. SECTION 313 SUPPLIER NOTIFICATION: THIS
PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS SUBJECT TO THE
REPORTING REQUIREMENTS OF SECTI ON 313 OF EPCRA OF 1986 AND OF 40
CFR 372: SILVER CAS # 7440-22-4, 99.9%
======================================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HOUGHTO-SAFE 419-R
Preparer's Name:GARY CARL
CAGE:73277
Contract Num:SP0450-00-C-183
CAGE:73277
============= Composition/Information on Ingredients =============
Ingred Name:2-DIETHYLAMINOETHANOL
CAS:100-37-8
Code:F
RTECS #:KK5075000
< Wt:1.
OSHA PEL:50 MG/M3;10 PPM
ACGIH TLV:9.6 MG/M3;2 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHRONIC (RECURRENT) EFFECTS: UNKNOWN
FOR THIS PRODUCT. ACUTE EFFECTS: INHALATION: AVOID BREATHING
PRODUCT MISTS. BREATHING MISTS MAY CAUSE IRRITATION OF UPPER
RESPIRATORY TRACT. PERSONS WITH CHRONIC R ESPIRATORY DISEASE MAY
SHOW INCREASED SYMPTOMS DUE TO IRRITATION. SKIN: MILD IRRITANT.
INGESTION: AVOID INGESTION. MAY NAUSEA, DIZZINESS, DIAHRREA,
VOMITING. REPEATED OVEREXPOSURE MAY LEAD TO LIVER AN D KIDNEY
DAMAGE. EYE: MODERATE IRRITANT.
Explanation of Carcinogenicity:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Effects of Overexposure:CHRONIC (RECURRENT) EFFECTS: UNKNOWN FOR THIS
PRODUCT. ACUTE EFFECTS: INHALATION: AVOID BREATHING PRODUCT MISTS.
BREATHING MISTS MAY CAUSE IRRITATION OF UPPER RESPIRATORY TRACT.
PERSONS WITH CHRONIC R ESPIRATORY DISEASE MAY SHOW INCREASED
SYMPTOMS DUE TO IRRITATION. SKIN: MILD IRRITANT. INGESTION: AVOID
INGESTION. MAY NAUSEA, DIZZINESS, DIAHRREA, VOMITING. REPEATED
OVEREXPOSURE MAY LEAD TO LIVER AN D KIDNEY DAMAGE. EYE: MODERATE
IRRITANT.
Medical Cond Aggravated by Exposure:PERSONS WITH CHRONIC RESPIRATORY
DISEASE MAY SHOW INCREASED SYMPTOMS DUE TO IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO SOURCE OF FRESH AIR. SKIN: WASH WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND WASH BEFORE
REUSING. EYE: WASH WITH WATER 15 MINUTES; CONSULT PHYSICIAN.
INGESTION: INDUXE V OMITING. CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:N/A.
Fire Fighting Procedures:PRODUCT IS A FIRE RESISTANT FLUID; NOT
FLAMMABLE AS USED
Unusual Fire/Explosion Hazard:IF WATER IS REMOVED, PRODUCT WILL BURN.
CAN BE EXTINGUISHED WITH WATER, CARBON DIOXIDE, FOAM.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH AREA WITH WATER FOR SMALL QUANTITIES;
FOR LARGER QUANTITIES DIKE TO CONTAIN AND EITHER DISPOSE OF OR
REUSE DEPENDING ON CONDITION. POTENTIAL AS A POLLUTANT: MATERIAL IS
NOT CONSIDERED A POLLUTAN T IF EFFECTIVE WASTE DISPOSAL METHODS ARE
UTILIZED.
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STRONG OXIDIZERS. AVOID
INGESTION. WASH THOROUGHLY AFTER HANDLING. DO NOT ADD NITRITES TO
THIS PRODUCT.
Other Precautions:NO DATA PROVIDED BY RESPONSIBLE PARTY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:REQUIRED ONLY IF TLV IS EXCEEDED.
Ventilation:LOCAL EXHAUST IF MISTING; OTHER WISE GENERAL VENTILATION IS
ADEQUATE.
Other Protective Equipment:EYE WASH AND SAFETY SHOWER RECOMMENDED.
Work Hygienic Practices:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Supplemental Safety and Health
NO DATA PROVIDED BY RESPONSIBLE PARTY.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:=104.4C, 220.F
Decomp Temp:Decomp Text:NP
Vapor Pres:LIKE WATER
Vapor Density:LIKE H20
Spec Gravity:1.08
pH:9.5
Evaporation Rate & Reference:LIKE WATER
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, RED FLUID; AMINE ODOR
Percent Volatiles by Volume:45
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Hazardous Decomposition Products:THERMAL; OXIDES OF CARBON AND NITROGEN
=================== Toxicological Information===================
Toxicological Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
===================== Ecological Information =====================
Ecological:NO DATA PROVIDED BY RESPONSIBLE PARTY.
==================== Disposal Considerations ====================
Waste Disposal Methods:PROCESS THROUGH SEWAGE OR WASTE DISPOSAL SYSTEM
WHICH PROVIDES BIOLOGICAL OXIDATION. (IF WATER CONTENT IS BELOW
35%, MATERIAL MAY BE BURNED WITH FUEL OIL).
=================== MSDS Transport Information ===================
Transport Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 313: THIS PRODUCT CONTAINS NO TOXIC
CHEMICAL SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF
1986 AND 40 CFR PART 372.
Federal Regulatory Information:CERCLA REPORTABLE QANTITY (LBS): NONE.
RCRA HAZARDOUS WASTE NUMBER: N/A. ALL OF THE COMPONENTS IN THIS
PRODUCT ARE ON THE TSCA INVENTORY.
State Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================= Other Information =======================
======================================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:47-077 AND 47-078, SONOMERIC 2 BASES, TYPE M(SUP DAT)
Kit Part:Y
Preparer's Name:MARK HORTON
CAGE:CHEMR
CAGE:CHEMR
CAGE:63472
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM OXIDE
CAS:1305-78-8
RTECS #:EW3100000
Fraction by Wt: 10-15%
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:CLAY (KAOLIN); (KAOLIN CLAY)
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 8-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:ASPHALT (PETROLEUM)
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:5 MG/M3; (FUME)
Ingred Name:STODDARD SOLVENT VP: 2 @ 20C; LEL: 1%
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 6-8%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:ARYL MERCURY COMPOUNDS (SARA 313) (CERCLA)
CAS:7439-97-6
Fraction by Wt: <0.4%
OSHA PEL:C, 0.1 MG/M3
ACGIH TLV:S,0.025 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SUP DAT: GRINDING, COULD CONTAIN PARTICLES OF CALCIUM
OXIDE, KAOLIN CLAY/PETRO ASPHALT. CHRONIC OVEREXP TO DUSTS (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: OF THESE SUBSTANCES MAY CAUSE DELAYED & SERIOUS LUNG
INJURY. PRLNG/RPTD EXPOS TO ISOCYANATES CAN LEAD TO (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: SKIN SENSIT. FOR PERS SO SENSIT EVEN BRIEF EXPOS TO
ISOCYANATE CAN PRDCE REDDENING, SWELL, RASH/BLISTERS.(ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: PRLNG & RPTD EXPOS TO ISOCYANATES CAN LEAD TO RESP
SENSIT. IN SUCH PERS BRIEF EXPOS TO ISOCYANATES AT (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: LEVELS < TLV CAN PRDCE CHEM ASTHMA, & NONSPECIFIC
ASTHMATIC CNDTNS. RPTS HAVE ASSOC RPTD & PRLNG OCCUP (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG; ALSO
LIVER & KIDNEY DMG, MUC MEMB IRRIT. INTENTINAL MISUSE(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: BY DELIBERATELY INHALING CONTENTS MAY BE
HARMFUL/FATAL. RPTD & PRLNG OVEREXP TO MERCURY CMPDS, ESP THRU (ING
14)
RTECS #:9999999ZZ
Ingred Name:ING 13: SKIN CONT, CAN PRDCE NEUROLOGIC TOX EFTS (CHRONIC
NAUS, VOMIT, ABDOM PAIN, PARTIAL PARAL OF LIPS & (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: MOUTH, CNS DEPRESS). SOMETIMES THESE SYMPS MAY NOT
APPEAR FOR PERIODS OF DAYS TO WKS AFTER EXPOS ENDED. (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: MERCURY APPEARS ON THE NAVY OCCUP CHEM REPRO HAZ
LIST. SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: CONCERNING LATEST HAZ LIST INFO & SAFE HANDLING &
EXPOSURE INFORMATION .
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: OBTAIN IMMED MED ATTN. INGEST: OBTAIN IMMED
MED ATTN. DO NOT INDUCE VOMIT. SHOULD VOMIT OCCUR, (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: BE SURE TO KEEP VICTIM'S HEAD BELOW HIPS TO PREVENT
ASPIRATION OF VOMITUS INTO THE LUNGS.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: DIKE/IMPOUND SPILLED LIQ. COVER SPILL W/ABSORB
CMPD (VERMICULITE, CLAY/SAND). USE NON-SPK TOOLS TO (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: SWEEP/SHOVEL INTO CONTRS. COVER LOOSELY & REMOVE TO
WELL-VENTD WASTE AREA. REPEAT SORBENT/SWEEP CYCLE (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: UNTIL SPILL HAS DRIED UP. RINSE SPILL AREA THORO
W/WATER. FLUSH RINSING TO SANITARY SEWER/SOAK UP WITH (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22: ABSORB MATL. DO NOT DISCHARGE UNDILUTED PROD TO
SANITARY SEWER. DO NOT DISCHARGE PROD/CLEANUP WASTES TO (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: LAKES, STREAMS, PONDS OR SEWER. AVOID CONTACT WITH
EYES AND SKIN.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: MOD IRRIT. MAY CAUSE
TEARING, REDDENING & REVERSIBLE CORNEAL INJURY. SKIN: SEV IRRIT.
PROD MAY CONTAIN TRACE AMTS OF ISOCYANATE, GEN REGARDED AS PRIMARY
SKIN IRRIT. CONT MAY CAUSE DERM, AL LERGIC RESPONSES &, IN
SENSITIVE PERS, REDNESS, SWELL & BLISTERS. MERCURY CMPDS ARE POTENT
SKIN SENSIT(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: & TOXINS, KNOWN TO PRDCE SWELL,
BLISTERS & ULCERS. INHAL: SEV IRRIT. MAY PRDCE IRRIT OF RESP TRACT,
COUGHING, CHEST DISCOMFORT, SHORTNESS OF BRTH. PERS W/HISTORY OF
EXPOS TO ISOCYANATES CAN DEVELOP MORE SEV SYMPS, SUCH AS
BRONCH,BRONCH SPASMS, & PULM EDEMA (FLUID IN LUNGS). FOR MOST PERS
THESE EFTS (SUP DAT)
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY OR SKIN
CONDITIONS MAY BE AGGRAVATED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN. IF NEC,
GENTLY HOLD EYELIDS OPEN DURING FLUSH. SKIN: REMOVE CONTAM CLTHG &
SHOES. WASH AFFECTED AREAS THORO W/SOAP & WATER. WIPE/FLUSH
AFFECTED SKIN W /ISOPROPYL RUBBING ALCOHOL. WASH AGAIN THORO W/SOAP
& WATER. IF IRRIT PERSISTS, SEEK MED ATTN. INHAL: MOVE TO FRESH
AIR. IF DFCLTY BRTHG, GIVE OXYGEN. ADMIN ARTF RESP IF NOT BRTHG.
(ING 18)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:105F,41C
Lower Limits:0.9%
Upper Limits:7.0%
Extinguishing Media:WATER SPRAY (FOG), FOAM, DRY CHEMICAL OR CARBON
DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
CONTRS EXPOSED TO FIRE SHOULD BE KEPT COOL W/WATER SPRAY. WATER
STREAM DIRECTED INTO FIRE MAY CAUSE (SUP DAT)
Unusual Fire/Explosion Hazard:CLSD CONTRS MAY EXPLODE DUE TO BUILD UP
OF PRESS WHEN EXPOSED TO HEAT. THERMAL DECOMP/COMBUST OF PROD MAY
GENERATE IRRIT &/TOX GASES. VAP IS HVR/AIR & (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA & REMOVE ALL SOURCES OF IGNIT.
EVACUATE UNNEC PERS. WIPE UP SM SPILLS W/RAGS/TOWELS. PUT SPENT
RAGS/TOWELS IN LOOSELY COVERED CONTRS IN WELL-VENTD AREA. LGE
SPILLS SHOULD BE HANDLED CAREFULL Y. PUT ON NIOSH APPRVD RESP PROT.
(ING 20)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE VAPORS. AVOID CONTACT
WITH EYES, CLOTHING, AND SKIN. KEEP CONTAINER CLOSED WHEN NOT IN
USE. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DO NOT TAKE INTERNALLY. WEAR PROTECTIVE CLOTHING AT
ALL TIMES. USE ONLY WITH ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH APPROVED RESPIRATORY PROTECTION WHEN
THE PRODUCT IS MIXED OR APPLIED IN A POORLY VENTILATED AREA OR IF
WORKPLACE LEVELS OF INGREDIENTS EXCEED THE TLV. FOLLOW APPLICABLE
FEDERAL, STATE, AND LOCAL REGULATIONS.
Ventilation:USE LOCAL EXHAUST AS NEEDED TO KEEP VAPOR/DUST LEVELS BELOW
RECOMMENDED LIMITS.
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
CLEAN PROT CLTHG TO COVER ARMS & LEGS & KEEP EXPOS TO A MINIMUM.
Work Hygienic Practices:WASH THOROUGHLY AFTER USING.
Supplemental Safety and Health
TRADE NAME/PART #: (-077) & TYPE H (-078). FIRE FIGHT PROC: FROTHING
W/SUBSEQUENT SPREAD OF FIRE. EXPLO HAZ: MAY TRAVEL ALONG
GROUND/FLOOR & BE IGNITED AT LOCATIONS DISTANT FROM SOURCE. EFTS OF
OVEREX P: ARE REVERSIBLE. INGEST: MAY CAUSE IRRIT. CHRONIC: DUST
GENERATED BY ABNORM ACTIVITIES, SUCH AS SANDING OR (ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>240F,>116C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.13
Evaporation Rate & Reference:SLOWER THAN N-BU AC
Solubility in Water:SLIGHT (<0.1%)
Appearance and Odor:SMOOTH PIGMENTED VISCOUS LIQUID, TYPICAL PAINT
THINNER ODOR
Percent Volatiles by Volume:6-8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, AMINES, STRONG OXIDANTS, STRONG BASES OR ACIDS.
Stability Condition to Avoid:CONTACT WITH WATER VAPOR. SOURCES OF
IGNITION. LONG TERM EXPOSURE TO ELEVATED TEMPERATURES.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN,
HYDROGEN CYANIDE GAS, ORGANIC MERCURY COMPOUND, OTHER ACRID AND
TOXIC FUMES.
Conditions to Avoid Polymerization:PRODUCT CONTAINS ISOCYANATE. CONTACT
W/MOISTURE OR OTHER MATERIALS THAT REACT W/ISOCYANATES MAY CAUSE
POLYMERIZATION.
==================== Disposal Considerations ====================
Waste Disposal Methods:REVIEW ALL LOCAL, STATE AND FEDERAL REGULATIONS
CONCERNING HEALTH AND POLLUTION FOR APPROPRIATE DISPOSAL
PROCEDURES. DO NOT INCINERATE CLOSED CONTAINERS. RCRA WASTE # D001.
RQ: 100 LBS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-213-3279
Product ID: SO-SURE CORROSION PREVENTATIVE COMPOUND, (0954-001)
Cage: 0FTT5
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0FTT5
=======================================================
Contractor Summary
=======================================================
Cage: 0FTT5
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: CORROSION PREVENTIVE COMPOUND
Specification Number: MIL-C-81309E
Type/Grade/Class: TYPE 2; CLASS 1
Unit of Issue: GL
UI Container Qty: 4
=======================================================
Ingredients
=======================================================
Cas: 64742-88-7
RTECS #: SE7544000
% Wt: 47.50
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM
------------------------------
Cas: 25619-56-1
% Wt: 40.00
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 95-63-6
RTECS #: DC3325000
% Wt: 2.50
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 25 PPM
ACGIH TLV: 25 PPM; 9495
------------------------------
RTECS #: 9999999VO
% Wt: 50%
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT EST.
ACGIH TLV: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NON-MINERAL SPRTS PRT:INGEST 3 G/KG RATS
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: REPEATED & PROLONGED OVEREXPOSURE: PERMANENT BRAIN
& NERVOUS SYSTEM DAMAGE. IN CONFINED AREAS, HIGH CONCENTRATIONS VAPOR
ANESTHETIC. IRRITATION TO SKIN & RESP TRACT. OVEREXPOSURE MAY RESULT IN
LIGHT H EADEDNESS, STAGGERING, GIDDINESS, NAUSEA. HARMFUL IF SWALLOWED.
SEVERE EYE IRRITATION.
Signs And Symptions Of Overexposure: IRRITATION TO EYES, THROAT AND RESPIRATORY
TRACT. MAY CAUSE HEADACHES, NAUSEA, AND VOMITING. CONTACT WITH HEATED
MATERIAL MAY CAUSE THERMAL BURNS.
Medical Cond Aggravated By Exposure: CONTACT MAY CAUSE DEFATTING, OIL ACNE,
IRRITATION OR ALLERGIC REACTION IN SENSITIVE INDIVIDUALS.
First Aid: FOR CONTACT WITH SKIN OR CLOTHES, WASH WITH SOAP & WATER; WASH
CLOTHES BEFORE REUSE. FOR CONTACT WITH EYES, FLUSH WITH WATER FOR 15 MINUTES.
CONTACT A PHYSICIAN/OPHTHALMOLOGIST IMMEDIATELY. IF SWALLOW ED, DO NOT INDUCE
VOMITING. GET IMMEDIATE MEDICAL AID. IF INHALED, REMOVE TO FRESH AIR, GIVE
ARTIFICIAL RESPIRATION IF NECESSARY & GET MEDICAL AID. NEVER GIVE
ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION AND VENTILATE AREA.
AVOID BREATHING VAPORS. PICK UP SPILLAGE WITH INERT ABSORBENT MATERIAL.
ATTEMPT TO RECOVER. KEEP PETROLEUM PRODUCTS OUT OF STREAMS AND WATERWAYS.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH APPLICABLE FEDERAL,
STATE, & LOCAL REGULATIONS. KEEP OUT OF STREAMS AND WATERWAYS. CONTAINS
2.0% BARIUM - DISPOSE OF AS REQUIRED FOR MATERIALS CONTAINING EXTRACTABLE
BARI UM ACCORDING TO US EPA-RCRA.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN.
Other Precautions: AVOID CONTACT WITH EYES OR SKIN. USE WITH GOOD VENTILATION.
READ ENTIRE LABEL BEFORE USING. FOLLOW ALL LABEL DIRECTIONS. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING & INHALING OR SWALLOWING CONTE NTS
MAY BE HARMFUL OR FATAL.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TOC
Flash Point Text: 140F,60C
Lower Limits: NOT EST.
Upper Limits: NOT EST.
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY.
AVOID SPREADING ANY BURNING LIQUID WITH WATER SPRAY.
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE.WATER MAY BE USED TO KEEP
FIRE EXPOSED CONTAINERS COOL. WEAR SCBA. USE SHIELDING TO PROTECT AGAINST
BURSTING,RUPTURING,VENTING CNTNRS.
Unusual Fire/Explosion Hazard: WATER STREAMS ON BURNING MATERIAL MAY SPREAD
FIRE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
Ventilation: LOCAL EXHAUST: PREFERRED. MECHANICAL (GENERAL): ACCEPTABLE AT
POINT OF MIST OR SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN. EYE WASH
STATION. SAFETY SHOWER.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DO NOT EAT, DRINK, OR SMOKE
WHILE USING PRODUCT.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: F4
B.P. Text: >150F,>66C
M.P/F.P Text: NR
Decomp Text: NA
Vapor Pres: <1.0
Vapor Density: >1.0
Spec Gravity: 0.858 (WATER=1)
PH: NA
Solubility in Water: NIL
Appearance and Odor: BROWN FLUID WITH THE ODOR OF MINERAL SPIRITS
Percent Volatiles by Volume: 50.0
Corrosion Rate: NA
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: TEMPERATURES ABOVE FLASH POINT AND OPEN FLAMES.
Materials To Avoid: STRONG OXIDIZING AGENTS
Hazardous Decomposition Products: COMBUSTION MAY RESULT IN UNDEFINED ORGANICS
AND OXIDES OF CARBON & OXIDES OF SULFUR.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 56827
Product ID: SO-SURE CORROSION PREVENTATIVE COMPOUND, (0954-001)
Review Date: 09/17/1996
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: GL
Container QTY: 4
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: SO-SURE CORROSION PREVENTATIVE COMPOUND, (0954-001)
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Street: 8833 FLEISCHER PLACE
Zipcode: 63134
Label Required IND: Y
Date Of Label Review: 10/12/1999
Status Code: A
Origination Code: G
Hazard And Precautions: REPEATED & PROLONGED OVEREXPOSURE: PERMANENT BRAIN
& NERVOUS SYSTEM DAMAGE. IN CONFINED AREAS, HIGH CONCENTRATIONS VAPOR
ANESTHETIC. IRRITATION TO SKIN & RESP TRACT. OVEREXPOSURE MAY RESULT IN
LIGHT H EADEDNESS, STAGGERING, GIDDINESS, NAUSEA. HARMFUL IF SWALLOWED.
SEVERE EYE IRRITATION.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DRY IMAGERS & IC-6R233
CAGE:EO482
CAGE:7S237
CAGE:EO482
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL-A-PROPYLENE OXIDE FUMARATE
ACGIH TLV:NOT SPECIFIED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:SILICA, AMORPHOUS, DUST
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <2.0%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3; 8990
Ingred Name:ZINC STEARATE
CAS:557-05-1
RTECS #:ZH5200000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Effects of Overexposure:USUAL DISCOMFORT OF INHALATION IN HEAVY DUST
CONDITIONS.NOT A POISON
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
NEED;EYES/SKIN:FLUSH W LG AMTS H*2O FOR 15 MIN;INGEST:RINSE MOUTH;
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER,FOAM,DRY CHEMICALS.
Fire Fighting Procedures:USE NIOS/MSHA APPROVED SCBA IN CONFINED AREA.
Unusual Fire/Explosion Hazard:DRY IMAGER IS COMBUSTIBLE,EXPLOSIVE
LIMITS OF DRY IMAGER PARTICLES SUSPENDED IN AIR=COAL DUST.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;VACUUM OR SWEEP
UP (PREFERABLY WITH A SWEEPING COMPOUND)
======================Handling and Storage ======================
Handling and Storage Precautions:USE NORMAL HANDLING PROCEDURES.
Other Precautions:AVOID CONTACT WITH SKIN AND EYES;DO NOT INHALE
VAPORS,DUST/FUMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR DUST/MIST
IF ABOVE TLV.
Ventilation:MECH(GEN)OR LOCAL EXHAUST THAT PROVIDES ADEQUATE
VENTILATION
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
MSDS UNDATED;
================== Physical/Chemical Properties ==================
HCC:V7
Spec Gravity:1.1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER,FAINT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOTED NONE
Stability Condition to Avoid:NONE NOTED
Hazardous Decomposition Products:NONE NOTED
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE;DISPOSE OF COLLECTED MATERIAL
IN ACCORDANCE WITH LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:290MS116P001
CAGE:0872X
CAGE:0872X
CAGE:49956
============= Composition/Information on Ingredients =============
Ingred Name:CESIUM 137
================== Accidental Release Measures ==================
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:A3
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:870 8265 BIOMAX CHEMILUMINESCENT DETECTION SYSTEM PRO GOAT
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM PHOSPHATE, MONOBASIC
CAS:7558-80-7
RTECS #:WA1900000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:THIMEROSAL
CAS:54-64-8
RTECS #:OV8400000
Fraction by Wt: < 0.1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BOVINE SERUM ALBUMIN
Fraction by Wt: < 0.1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PEROXIDASE AFFINIPURE GOAT ANTI-RABBIT IGG PROTEIN
Fraction by Wt: 95-100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY CAUSE TRANSIENT EYE IRRITATION. LOW
SKIN CONTACT HAZARD FOR RECOMMENDED HANDLING. EXPECTED TO BE A LOW
INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMEEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:COMBUSTIBLESOLID
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSTION PRODUCTS. POWDERED MATERIAL MAY FORM
EXPLOSIVE DUST-AIR MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING DUST. AVOID CONTACT
WITH EYES, SKIN, AND CLOTHING. WASH WITH SOAP AND WATER. KEEP
CONTAINER TIGHTLY CLOSED.
Other Precautions:REFER TO NFPA PAMPHLET NO. 654, "PREVENTION OF FIRE
AND DUST EXPLOSIONS IN THE CHEMICAL, DYE, PHARMACUETICAL, AND
PLASTICS INDUSTRIES." USE WITH ADEQUATE VENTILATION. KEEP FROM
CONTACT WITH OXIDIZING MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:F8
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:WHITE SOLID POWDER, NO ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1506 ALMOND DECORATOR PAINTS
Resp. Party Other MSDS Num.:DEC/KR-1
CAGE:TO019
CAGE:TO019
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
= Wt:14.
OSHA PEL:1800 MG/M3;1000 PPM
Ingred Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
= Wt:6.
ACGIH TLV:1900 MG/M3;800 PPM
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
= Wt:37.
OSHA PEL:2400 MG/M3;1000 PPM
ACGIH TLV:1780 MG/M3;750 PPM
ACGIH STEL:2380 MG/M3;1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYLBENZENE
CAS:100-41-4
RTECS #:DA0700000
= Wt:2.
OSHA PEL:435 MG/M3;100 PPM
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:543 MG/M3;125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
= Wt:9.
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE
CAS:78-93-3
RTECS #:EL6475000
= Wt:4.
OSHA PEL:590 MG/M3;200 PPM
ACGIH TLV:590 MG/M3;200 PPM
ACGIH STEL:885 MG/M3;300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ISOBUTYL KETONE
CAS:108-10-1
RTECS #:SA9275000
= Wt:3.
OSHA PEL:410 MG/M3;100 PPM
ACGIH TLV:205 MG/M3;50 PPM
ACGIH STEL:307 MG/M3;75 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1-METHOXY-2-PROPYL ACETATE
CAS:108-65-6
RTECS #:AI8925000
= Wt:7.
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
= Wt:6.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME
OVEREXPOSURE MAY RESULT IN UNCONSCIOUSNESS AND POSSIBLY DEATH.
CHRONIC: PROLONGED OVEREXPOSURE TO SOLVENTINGREDIENTS MAY CAUSE
ADVERSE EFFECTS TO LIVER, URINARY, BLOOD-FORMING, CARDIOVASCULAR &
REPRODUCTIVE SYSTEMS. METHYL ETHYL KRTONE MAY INCREASE THE NERVOUS
SYSTEM EFFECTS OF OTHER SOLVENTS. METHYL ETH YL KETONE MAY INCREASE
THE NERVOUS SYSTEM EFFECTS OF OTHER SOLVENTS. REPORTS HAVE
ASSOCIATED REPEATED OR PROLONGED OVEREXPOSURE TO SOLVENTS WITH
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NO INGREDIENT IN THESE PRODUCTS IS AN
IARC, NTP OR OSHA LISTED CARCINOGEN.
Effects of Overexposure:HEADACHE, DIZZINESS, NAUSEA, AND LOSS OF
COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO VAPORS OR
SPRAY MISTS. TENDERNESS AND ITCHING OR BURNING SENSATION MAY
INDICATE EYE OR EXCESSIVE SKIN EXP OSURE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:IF INHALED: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM AND QUIET. IF ON SKIN: WASH AFFECTED AREA
THOROUGHLY WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND
LAUNDER BEFORE RE USE. IF IN EYES: FLUSH WITH LARGE AMOUNTS OF
WATER FOR 15 MINUTES. GET MEDICAL ATTENTION. IF SWALLOWED: NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. DO NOT INDUCE
VOMITING. GIVE CONSCIOUS PA TIENT SEVERAL GLASSES OF WATER. SEEK
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<-17.6C, 0.F
Lower Limits:1.0
Upper Limits:13.1
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS SHOULD BE USED. WATER SPRAY MAY
BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE. WATER
MAY BE USED TO COOL CLOSED CO NTAINERS TO PREVENT PRESSURE BUILD-UP
AND POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME
HEAT.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT. ISOLATE FROM
HEAT, ELECTRICAL EQUIPMENT, SPARKS & OPEN FLAME. APPLICATION TO HOT
SURFACES REQUIRES SPECIAL PRE CAUTIONS. DURING EMERGENCY CONDITIONS
OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAME. VAPORS WILL ACCUMULATE READILY & MAY IGNITE EXPLOSIVELY.
DURING USE & UNTIL ALL VAPORS ARE GONE. KEEP AREA VENTILATED-DO NOT
SMOKE-EXTINGUISH ALL FLAMES, PILO T LIGHTS & HEATERS -TURN OFF
STOVES, ELECTRIC TOOLS & APPLIANCES, ANY OTHER SOURCES OF IGNITION.
Other Precautions:CONSULT NFPA CODE. USE APPROVED BONDING & GROUNDING
PROCEDURES. CONTENTS UNDER PRESSURE. DO NOT PUNCTURE, INCINERATE,
OR EXPOSE TO TEMPERATURE ABOVE 120F. HEAT FROM SUNLIGHT, RADIATORS,
STOVES, HOT WA TER, & OTHER HEAT SOURCES COULD CAUSE CONTAINERS TO
BURST. DO NOT TAKE INTERNALLY. KEEP OUT OF THE R EACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION
AGAINST INGREDIENTS. WHEN SANDING OR ABRADING THE DRIED FILM,
WEAR A DUST/MIST RESPIRATOR APPROVED BY NIOSH/MSHA FOR DUST WHICH
MAY BE GENERATED FROM THIS PRODUCT.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
EXPOSURE TO MATERIALS IN SECTION II IS MAINTAINED BELOW APPLICABLE
EXPOSURE LIMITS.
PRODUCTS .
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE.
Supplemental Safety and Health
INTENTIONAL MISUSE OF DELIBERATELY CONCENTRATING AND INHALING THE
CONTENTS CAN BE HARMFUL OR FATAL.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:<0 - 302F
Vapor Density:>AIR
VOC Grams/Liter:3.
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:COLOR: ALMOND.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENTS.
=================== Toxicological Information===================
Toxicological Information:RATS EXPOSED TO TITANIUM DIOXIDE DUST AT 250
MG/M3 DEVELOPED LUNG CANCER, HOWEVER, SUCH PRESSURE ELEVELS ARE NOT
ATTAINABLE IN THE WORKPLACE. . WEIGHT PER GALLONS (LBS.): 6.69. VOC
AS A PERCENT BY WEI GHT PER BAAQMD & CARB: 45.0.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE. DEPRESSURIZE CONTAINER.
DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL REGULATIONS
REGARDING POLLUTION.
===================== Regulatory Information =====================
SARA Title III Information:INGREDIENTS SUBJECT TO THE REPORTING
REQUIREMENTS OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT
(SARA) SECTION 313. 40 CFR 372.65 C: ETHYLBENZENE, XYLENE,METHYL
ETHYL KETONE AND METHYL ISOBUTY L KETONE.
Federal Regulatory Information:TSCA CERTIFICATION: ALL CHEMICALS IN
THESE PRODUCTS ARE LISTED, OR ARE EXEMPT FROM LISTING, ON THE TSCA
INVENTORY.
State Regulatory Information:WARNING: THESE PRODUCTS CONTAIN A
CHEMICAL/S KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER AND
BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
======================= Other Information =======================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:03GN137 MIL-C-46168, OKIVE DRAB, TYPE II
CAGE:33461
CAGE:33461
============= Composition/Information on Ingredients =============
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 20%
Other REC Limits:N/K
OSHA PEL:S,100 PPM
ACGIH TLV:S, 5 PPM; 9192
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 10%
Other REC Limits:N/K
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ACETATE (SARA III)
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 10%
Other REC Limits:N/K
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:DIBUTYL TIN DILAURATE (AS TIN)
CAS:77-58-7
RTECS #:WH7000000
Fraction by Wt: <0.5%
Other REC Limits:N/K
OSHA PEL:S, 0.1 MG/M3
ACGIH TLV:S, 0.1 MG/M3; 8990
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K (FKP N)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NIOSH STUSIED INDICATE 2-THOXYETHYL
ACETATE (CELLOSOLVE ACETATE DISORDERS IN LABORATORY ANIMALS (RATS
OR MICE) AND MAY HAVE THE POTENTIAL FOR CAUSING SIMILAR DISORDERS
IN HUMANS
Explanation of Carcinogenicity:N/A
Effects of Overexposure:INHAL:IRRIT OF THE RESP TRACT & ACUTE NERVOUS
SYS DEPRESS CHARACTERIZED BY THE FOLLOWING PROGRESSIVE STEPS:HDCH,
DIZZ, STAG GAIT,CONFUSN, UNCON OR COMA. ACUTE:SKIN & EYE CONTACT:
PRIMARY IRRIT. CHRONI C:REPEATED OVEREXPOSURE MAY RESULT IN
ALLERGIC SENSITIVITY.
Medical Cond Aggravated by Exposure:RESPIRATORY TRACT IRRITATION,
DERMITITIS, NAUSEA, VOMITING.
======================= First Aid Measures =======================
First Aid:VAPORS:RMV FROM EXPOS, RESTORE BRTHING, KEEP WARM & QUITE,
NOTIFY A PHYSICIAN. SPLASH(EYES):FLUSH IMMED W/PLENTY OF WATER FOR
15 MIN, TAKE TO A PHYSICIAN FOR MED ATTN. SPLASH(SKIN):WASH
AFFECTED AREA S W/WATER. REMOVE CONTAMINATED CLOTHING, CONSULT A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:24 F (-4 C)
Lower Limits:1.7
Upper Limits:N/K
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:USE PROTECTIVE EQUIPMENT & SCBA. WATER FOG MAY
BE USED TO COOL CONTAINERS TO PREVENT PRESSURE BUILD-UP IN CLOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP CNTNR TIGHTLY CL. ISOL FR HEAT, ELEC
EQPT. APDK & OPEN FLAME. CL CNTNR MAY EXDLD WHEN EXP TO EXTM HEAT.
APPL TO HOT SURF REQUIRES SPECIAL PRECAUTIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAME), HOT
SURFACES, SPARKS SORUCES). AVOID BREATHING VAPIRS. CONTAIN & REMOVE
WITH INERT ABSORBENT & NON-SPARKING TOOLS.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:STOREIN BUILDING DESIGNED TO COMPLY
WITH OSHA 1910.106. AVOID STORING NEAR HIGH TEMPERATURES, FIRE,
OPEN FLFAME, SPARK SOURCES.
Other Precautions:KEEP CLOSURES TIGHT & CONTAINER UPRIGHT TO PREVENT
LEAKAGE. DO NOT STORE OR USE NEAR HEAT, SPARKS OR FLAME. STORE ONLY
IN WELL VENT AREAS. PVNT PRLNG OR RPTD BREATHING OF VAPORS OR SPRAY
MIST. PRLNG O VEREXPOSURE CAN CAUSE AN ALLERGIC RCTN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APVD RPTR APPROPRIATE FOR EXPSR OF
CONCERN . OBS OSHA REG FOR RSPTR USE (29 CFR 1910.134)
OUTDOORS:NIOSH APVD RSPTR FOR PAINT, ENAMEL MISTS & ORGANIC VAPORS.
RSTR VENT AREAS:APVD CHE M/MECH FLTR DSGN TO RMV (SEE SUPP DATA )
Ventilation:VENTILATION APPROPRIATE FOR CONDITIONS OF USE.CONSULT
INDUSTRIAL HYGIENIST/SAFETY SPECIALIST FOR SPECIFIC GUIDANCE
Other Protective Equipment:USE LONG SLEEVES & LONG LEG CLOTHING. REMOVE
& WASH CONTAMINATED CLOTHING BEFORE REUSE. DO NOT REUSE CONTAMINED
CLTHG.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM. SMOKE IN SMOKINGAREA ONLY.
Supplemental Safety and Health
PH & CARCINOGENITY: FP N BP:(76C-156C). RESP PROT:A COMB OF
PARTICLULATED & VAPOR CONF AREAS: APD AIR LINE TYPE RSPTR OR HOOD
(MFR)' CONTAINER SIZE: 1 QUART. KEY1:F3.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:168F-313F
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:HTA
Spec Gravity:N/K
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:N/K
Appearance and Odor:N/K
Percent Volatiles by Volume:63.07
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS & BASES.
Stability Condition to Avoid:ELEVATED TEMPERATURES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE &
FEDERAL REGULATIONS. INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-1422 A-2 PART A
Kit Part:Y
Preparer's Name:J.C.S.
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:ACETAMIDE, N,N-DIMETHYL-; (DIMETHYL ACETAMIDE) (DMAC)
CAS:127-19-5
RTECS #:AB7700000
Fraction by Wt: 30%
OSHA PEL:10 PPM, S
ACGIH TLV:10 PPM, S
Ingred Name:DICHROMIC ACID, CALCIUM SALT (1:1); (CALCIUM DICHROMATE)
CAS:14307-33-6
RTECS #:HX7630000
Fraction by Wt: 20%
Ingred Name:MAGNESIUM DICHROMATE
CAS:13423-61-5
Fraction by Wt: 5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRIT. MAY CAUSE EYE DMG. SKIN:
IRRIT. PRLNGD EXPOS MAY CAUSE ALLERGIC SKIN RASH. TOX BY SKIN
ABSORP. LAB TESTS HAVE SHOWN THAT DERM APPLIC OF DMAC TO PREGNANT
RATS PRDCD FETAL ABNORM. PRLNGD EX POS TO HEXAVALENT CHROMIUM CMPDS
OVER PEL MAY CAUSE PAINLESS PENETRATING ULCERS OF SKIN. INHAL:
(MIST/ (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:DUST OF DRIED MATL) IRRIT OF MUC MEMB.
MAY CAUSE BRONCO ASTHMA. (VAP) IRRIT, NAUS, HDCH, WEAK, POSS LIVER
DMG. PRLNGD EXPOS TO HEXAVALENT CHROMIUM CMPDS OVER PEL MAY CAUSE
PENETRATING ULCERSOF MUC MEMB OF NOSE & PERFORATION OF
CARTILAGINOUS NASAL SEPTUM. INGEST: IRRIT OF STOMACH & INTESTINES.
NAUS, (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LUKE WARM WATER FOR AT LEAST 15 MINUTES,
CONSULT PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. IF SYMPTOMS
PERSIST, CONSULT PHYSICIAN. INHALATION: REMOVE TO FRESH AIR. IF
SYMPTOMS ARE PR ESENT CONSULT PHYSICIAN. INGESTION: CONSULT
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AND COVER SPILL WITH NON-OXIDIZABLE
ABSORBENT. SCOOP INTO CONTAINER. SPRINKLE SODIUM THIOSULFATE ON
RESIDUE. WORK INTO RESIDUE. SCOOP INTO DISPOSAL CONTAINER. CLEAN
AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WASH THOROUGHLY AFTER HANDLING AND
BEFORE SMOKING/EATING. AVOID INGESTION. DUE TO TOXICITY BY SKIN
ABSORPTION, AVOID ALL SKIN CONTACT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL VENTILATION TO MAINTAIN VAPOR BELOW PEL.
Other Protective Equipment:SKIN AREAS SUBJECT TO SPLASH SHOULD BE PROT
WITH NITRILE, BUTYL OR NATURAL RUBBER, OR POLYETHYLENE APRON OR
COVERALLS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: VOMITING, AND DIARRHEA. POSSIBLE LIVER AND KIDNEY
DAMAGE.
================== Physical/Chemical Properties ==================
Spec Gravity:1.45
Solubility in Water:COMPLETE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EASILY OXIDIZABLE MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN;
CHROMIUM COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE NO. D-007. DISPOSE OF SPILLAGE IN
COMPLIANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EXTRACTION SOLVENT, HYDROCHLOR Q4000 (SUPP DATA)
Kit Part:Y
CAGE:9Y176
CAGE:65297
CAGE:9Y176
============= Composition/Information on Ingredients =============
Ingred Name:EXTRACTION SOLVENT CONSISTS OF BUTYL DIGLYME/EMULSION
BREAKER (SEE ING 2)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHER, BIS (2-BUTOXYETHYL). (MFR'S INVALID CAS #112-73-23).
CAS:112-73-2
RTECS #:KN0350000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:SEPARATE AMPULE, FILLED PLASTIC SYRINGE & GLASS VIAL
CNTNG EXTRACTION SOLV & POWDERED EMULSION BREAKER (MFR).
RTECS #:9999999ZZ
Ingred Name:HAZ DECOMP PROD:OTHER SOLUTIONS ARE STABLE.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP:PERFORMING TEST ON SITE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . EYE:FLUSH W/LARGE AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES. SEEK MEDICAL ATTENTION. SKIN:FLUSH
W/LARGE AMOUNTS OF WATER. USE SOAP & WATER TO WASH AWAY ORGANIC
COMPON ENTS. INHAL:REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:243F,117C
Extinguishing Media:DO NOT USE WATER ON A SODIUM FIRE. DRY CHEMICAL,
FOAM, CO*2.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . DO NOT USE WATER.
Unusual Fire/Explosion Hazard:AVOID BREATHING SODIUM OXIDE FUMES WHICH
WILL FORM ON COMBUSTION. FLAMMABLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB COMPLETELY & DISPOSE OF AS ORGANIC
WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TEST KITS IN A COOL, DRY PLACE.
Other Precautions:FLAMMABLE LIQUID.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE REQUIRED DURING NORMAL USE.
Ventilation:PERFORM TEST ONLY IN A WELL VENTILATED AREA.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR APPROP SAFETY EQUIP WHEN (ING 5)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:CHLORINE/HALOGEN TEST KIT. NOTE:THIS MSDS IS
FOR EXTRACTION SOLVENT ONLY. USERS MUST REFER TO ALL PARTS A-G,
SAME NSN, TO BE INFORMED OF KIT CONTENTS/PRECS . HYDROCLOR Q 4000
CHLORINE/HALOGEN TEST KIT CONSISTSOF 1 TEST TUBE CNTNG 2 AMPULES, 1
TEST TUBE CNTNG 1 AMPULE & AQ SOLN, (ING 3)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:493F,256C
Vapor Pres:<0.01
Spec Gravity:0.881
Evaporation Rate & Reference:<0.01 (BUTYL ACETATE=1)
Solubility in Water:0.3%
Appearance and Odor:COLORLESS; ETHER-LIKE ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
KEEP FROM STRONG OXIDIZERS.
Stability Condition to Avoid:DO NOT EXPOSE BROKEN SODIUM AMPULE TO
MOISTURE.
Hazardous Decomposition Products:SODIUM WILL FORM HYDROGEN & SODIUM
OXIDE WHEN MOISTURE IS PRESENT. DIGLYME MAY FORM PEROXIDES ON EXPOS
TO AIR. (ING 4)
==================== Disposal Considerations ====================
Waste Disposal Methods:EXTRACTION SOLVENT VIAL:CONTAINS OIL SAMPLE &
EXTRACT SOLVENT. DISPOSE OF AS AN ORGANIC WASTE I/A/W ALL
APPLICABLE FEDERAL, STATE & LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:18247-8 POLYTETRAFLUOROETHYLENE
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:POLYTETRAFLUOROETHYLENE
CAS:116-14-3
RTECS #:KX4025000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HAMRFUL BY INHAL/INGEST/SKIN
ABSORPTION.MAY CAUSE EYE IRRIT.MAY CAUSE SKIN IRRIT.MATL MAY BE
IRRIT TO MUCOUS MEMBRANES & UPPER RESPIRATORY TRACT.TO BEST OF OUR
KNOWLEDGE THE CHEM/PHYS/TOXICOLOG ICAL PROPERTIES HAVE NOT BEEN
THOROUGHLY INVESTIGATED.
Explanation of Carcinogenicity:PER MSDS:IARC CANC REVIEW:HUMAN NO
ADEQUATE DATA/ANIMAL INADEQUATE EVIDENCE/GROUP 3.
Effects of Overexposure:HARMFUL BY INHAL/INGEST/SKIN
ABSORPTION.EYE/SKIN/MUC MEMBRANES/UPPER RESP TRACT IRRIT.
Medical Cond Aggravated by Exposure:NONE SPEC BY MFG.TARGET
ORGANS:TUMORIGENIC.
======================= First Aid Measures =======================
First Aid:IN CASE OF CONTACT IMMED FLUSH EYES W/COPIOUS AMTS OF WATER
FOR@LEASAT 15MINS.IN CASE OF CONTACT IMMED WASH SKIN W/SOAP/COPIOUS
AMTS OF WATER.IF INHAL REMOVE TO FRESH AIR.IF NOT BREATHING GIVE
ARTIFIC IAL RESPIRATION.IF BREATHING IS DIFFICULT GIVE OXYGEN.IF
SWALLOWED WASH OUT MOUTH W/WATER PROVIDED PERSON IS CONSC.CALL
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NP
Lower Limits:NP
Upper Limits:NP
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR APPROPRIATE
FOAM,WATER SPRAY.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING TO PREVENT CONTCT W/SKIN/EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
DISPOSAL.AVOD RAISING DUST.VENTILATE AREA & WASH SPILL SITE AFTER
MATERIAL PICKUP IS COMPLETE .
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR CLOSED.STORE IN COOL DRY
PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:OTHER PROTECTIVE CLOTHING.SAF SHOWER & EYE
BATH.
Work Hygienic Practices:AVOID INHAL.AVOID EYE/SKIN/CLOTHING
CONTACT.AVOID PROL/REPEATED EXPOSURE.WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NP
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:NP
Vapor Density:NP
Spec Gravity:2.00
pH:NP
Evaporation Rate & Reference:NP
Solubility in Water:NP
Appearance and Odor:WHITE POWDER
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MOLTEN ALKALI METALS, HALOGENS, FLUORINE, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID TEMPERATURES OVER 220C.
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE AND
CARBON DIOXIDE, HYDROGEN FLUORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:OBSERVE ALL LOCAL, STATE AND FEDERAL ENVIRO
REGULATIONS.DISSOLVE OR MIX MATL W/COMBUSTIBLE SOLVT & BURN IN CHEM
INCINERATOR EQUIPPED W/AFTERBURNER & SCRUBBER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:REFRIGERANT 12
CAGE:KO001
CAGE:2A580
CAGE:KO001
CAGE:3A676
============= Composition/Information on Ingredients =============
Ingred Name:DICHLORODIFLUOROMETHANE (SARA III)
CAS:75-71-8
RTECS #:PA8200000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:1000 PPM;VOL 8HR TWA
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:620,000PPM/3HR/MICE-800,000PPM/RAT/30MIN
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: CARDIOVASCULAR &
RESPIRATORY SYSTEMS MAY BE AFFECTED. GENERALIZED TINGLING
SENSATION, HUMMING IN EARS, APPREHENSION, SLURRED SPEECH, DECREASE
IN CONSCIOUSNESS W/AMNESIA, IRREG HEART BEAT . EYE IRRIT, CENTRL
NERV SYSTEM EFFECTS. SKIN: IRRIT. INGEST: FREEZING & FROSTBITE OF
TISSUE.*
Effects of Overexposure:* CHRONIC: INHALATION: VAPOR CAN BE FATAL.
CENTRAL NERVOUS SYSTEM DEPRESSION, SEDATION, LOSS OF COORDINATION,
MILD DEPRESSION. INGESTION: SLIGHT EFFECT ON LIVER.
Medical Cond Aggravated by Exposure:IN BRONCHITIC AND ASTHMATICS,
ARRTHYTMIAS OCCURED MOST FREQUENTLY AFTER SALBUTAMOL. HEART &
RESPIRATORY DISORDERS MAY PROVE SUSCEPTABLE TO ASPHYXIATION &
CARDIAC ARRHYTHMIAS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. KEEP WARM & AT REST. IF
LABORED BREATHING, GIVE OXYGEN. IF NOT BREATHING, START ARTIFICIAL
RESPIRATION. IF NO PULSE, START CPR. DON'T GIVE STIMULANTS. GET
MEDICAL AID. KEEP AT REST FOR 24 HRS. EYES/SKIN: FLUSH WITH WATER
OR SALINE SOLUTION 20 MIN. GET MEDICAL AID. INGESTION: KEEP PATIENT
CALM. GET MEDICAL AID. WARM SKIN SLOWLY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP UPWIND. VENTILATE ENCLOSED SPACES UNTIL
GAS IS DISPERSED. DO NOT SMOKE OR OPERATE INTERNAL COMBUSTION
ENGINES IN IMMEDIATE VICINITY. REPORT SPILL TO NATIONAL RESPONSE
CENTER, 1-800-424-8802 IF 5, 000 LBS OR MORE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE & USE WITH ADEQUATE VENTILATION.
NEVER USE IN A CLOSED OR CONFINED SPACE. STORE IN COOL PLACE
(<120F).
Other Precautions:DO NOT BREATHE VAPOR. AVOID CONTACT WITH EYES, SKIN &
CLOTHING. CFC-12 IS SHIPPED AND STORED AS A LIQUIFIED, COMPRESSED
GAS UNDER PRESSURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF CONCENTRATIONS EXCEED TLV (1,000 PPM) USE AN
APPROVED RESPIRATOR. IN VERY HIGH CONCENTRATIONS, SELF-CONTAINED
BREATHING APPARATUS SHOULD BE USED.
Ventilation:LOCAL EXHAUST MAY BE NECESSARY TO REDUCE CONCENTRATIONS
BELOW TLV (1,000 PPM).
Work Hygienic Practices:NOT FOR FOOD, DRUG OR COSMETIC USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-22F,-30C
Vapor Pres:79.8 PSIG
Vapor Density:2.32 **
Spec Gravity:1.31 @77F;1 ATM
Viscosity:N/K* @ 77F
Evaporation Rate & Reference:N/K ** LB/FT3 @ 77F
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS LIQUID AND VAPOR; ODOR VERY SLIGHT
ETHEREAL TO ODORLESS.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ELASTOMERS, ALKALI OR ALKALINE EARTH METALS, POWDERED ALUMINUM, ZINC,
BERYLLIUM, FINELY GROUND MAGNESIUM.
Stability Condition to Avoid:AVOID CONDITIONS WHERE CFC-12 MAY CONTACT
OPEN FLAMES OR EXTREMELY HOT METAL SURFACES.
Hazardous Decomposition Products:HF, HCL, AND TRACES OF CARBONYL HALIDE
(I.E. PHOSGENE).
==================== Disposal Considerations ====================
Waste Disposal Methods:THE EPA HAZARDOUS WASTE NUMBER IS U075.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PHENOLINE THINNER
CAGE:06634
CAGE:06634
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 60%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-ETHOXYETHANOL (EGEE) (SARA III)
CAS:110-80-5
RTECS #:KK8050000
Fraction by Wt: 20%
OSHA PEL:S,200 PPM
ACGIH TLV:S, 5 PPM; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PENTOXONE, 4-METHOXY-4-METHYL-PENTONONE-2
CAS:107-70-0
RTECS #:SA9185000
Fraction by Wt: 20%
ACGIH TLV:100PPM, MFR
===================== Hazards Identification =====================
Effects of Overexposure:VAPOR: EYE IRRIT, IRRIT OF RESP TRACT, DIZZ,
NAUSEA
======================= First Aid Measures =======================
First Aid:INH: MOVE TO FRESH AIR. CALL MD. EYE: IMMED FLUSH W/WATER AT
LEAST 15 MIN. CALL MD. SKIN: WASH THOROUGHLY W/MILD SOAP & WATER.
===================== Fire Fighting Measures =====================
Flash Point:77F PMCC
Lower Limits:1.0
Upper Limits:15.7
Extinguishing Media:USE DRY CHEM OR CHEM FOAM SUITABLE FOR SLVNTS
Fire Fighting Procedures:COOL BELOW IGNITION TEMP W/CO*2 OR SMOTHER
W/CHEM FOAM
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID BRTHNG SLVNT VAPORS. EXTINGUISH ALL
SOURCES OF IGNITION. AVOID SKIN CNTCT. SOAK UP LIQ W/SAWDUST OR
RAGS. REMOVE. FLUSH W/WATER IF POSS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY AREA W/VENT
SUITABLE FOR STORING GIVEN SLVNTS.
Other Precautions:PROVIDE RESP PROT AGAINST SMOKE, FUMES GENERATED
DURING BURNING, DUSTS GENERATED DURING REMOVAL OF DRY COATING BY
ABRADING OPERATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD RESP PROT IN ENCLOSED AREAS
Ventilation:MECH, ADEQUATE EXHST FROM BOTTOM
Other Protective Equipment:PROTECTIVE CREAMS & CLOTHING REC TO AVOID
SKIN CNTCT
Supplemental Safety and Health
VAP PRESS, VAP DNSTY, EVAP RATE ARE THAT OF XYLOL. % VOL >99%. SPEC
GRAVITY:0.89 + OR -0.02.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:275-318
Vapor Pres:11
Vapor Density:3.3
Evaporation Rate & Reference:0.68 N-BUTYL ACE
Appearance and Odor:CLEAR, WATER-WHITE LIQ, PUNGENT AROMATIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:SPARKS & OPEN FLAME
Hazardous Decomposition Products:CO, CO*2, ALDEHYDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW LOCAL, STATE, FED REG
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:WELDWOOD VINYL FLOOR COVERING ADHESIVE 3076
Preparer's Name:C J WARWICK
CAGE:90300
CAGE:90300
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <4%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <2%
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:LIQ & VAP IRRIT EYES,SKIN,RESP
TRACT.MAY CAUSE CNS
DEPRESS,HDCH,DIZZ,FATIGUE,NAUSEA,UNCON.INGEST:CAUSES
NAUSEA,VOMIT,DIARRHEA,DEPRESSED RESP.OVEREXPOS BY INHAL IS UNLIKELY
SINCE VAP PRESS OF PRO D IS LOW.IF ASPIRATED, CAUSES
COUGHING,GAGGING,DISTRESS & RAPIDLY DEVELOPING PULMONARY EDEMA.(SEE
EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CHRONIC:LIQ MAY CAUSE DERM AFTER
PRLNGD EXPOS TO SKIN.INGEST:EXCESS MAY LEAD TO RESP & CARDIAC
FAILURE & KIDNEY DAMAGE.NUMBER OF STUDIES INDICATED CONTINUAL
OVEREXPOS TO CONC SOLV VAPS OVER APERIOD OF TIME MAY LEAD TO PERM
CNS DAMAGE.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS,
IMPAIRED PULMONARY FUNCTIONS AND KIDNEY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR,RESTORE BREATHING IF NECESSARY.GET
MD. EYES:FLUSH W/LGE AMTS OF WATER FOR 15 MIN.GET MD. SKIN:WASH
W/SOAP AND WATER. GET MD IF IRRITATION DEVELOPS. INGEST:DO NOT
INDUCE VOMIT ING. IF VICTIM IS CONSCIOUS, GIVE WATEROR MILK. GET MD
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:ANY AND ALL
Fire Fighting Procedures:DO NOT USE STRAIGHT HOSE WATER STREAM.WEAR
NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT TO PROTECT
FROM COMBUSTION PRODUCTS.COOL EXPOSED CNTRS W/WATER
Unusual Fire/Explosion Hazard:CNTRS MAY EXPLODE IF EXPOSED TO EXTREME
HEAT. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS AND OPEN
FLAMES. DO NOT PUT IN CONTACT WITH OXIDIZING MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL:USE ABSORBENT MATL OR SCRAPE UP
DIRED MATL & PLACE IN CNTRS.LGE SPILL:ELIM ALL SOURCES OF IGNIT &
VENTILATE SPILL AREA.CONTAIN BY DIKING TO PVNT SPREADING.ABSORB
W/SAND,EARTH,OIL DRY/OTHERABSORB MATL/SHOVEL INTO CNTRS.(SEE SUPP
DATA)
Neutralizing Agent:SEE MATERIAL RELEASED/SPILLED ABOVE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTRS FROM HEAT,FLAMES,DIRECT
SUNLIGHT.DO NOT STORE AT TEMPS ABOVE 120F.PROVIDE CROSS VENT IN
STOR AREA.KEEP CNTRS TIGHTLY CLSD WHEN NOT IN USE.
Other Precautions:CONTAINS FLAMMABLE SOLVENT.VAP HARMFUL & MAY CAUSE
FLASH FIRE.HARMFUL OR FATAL IF SWALLOWED.USE ONLY W/ADEQUATE VENT &
ELIMINATE SOURCES OF IGNIT WHEN PROD IS USED.AVOID PRLNGD/RPTD
BRTHG OF SOLVENT V APS & CNTCT W/SKIN.WASH CONTAM CLTHG.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF 8-HOUR EXPOSURE LIMIT OR VALUE IS EXCEEDED
FOR ANY COMPONENT, USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN. (CONSULT OSHA 29 CFR 1910.134)
Ventilation:PROVIDE SUFFICIENT MECHANICAL VENT (LOCAL OR GENERAL
EXHAUST) TO MAINTAIN EXPOSURE BELOW PEL AND TLV.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL PROC:CLEAN UP REMAINING SPILL BY WASHING W/NONFLAM SOLV
(1,1,1-TRICHLOROETHANE).PVNT RUN-OFF TO SEWERS,STREAMS,LAKES/OTHER
BODIES OF WATER.NOTIFY LOCAL HLTH/WILDLIFE OFFICIALS IF RUN-OFF
OCCURS. WEAR PROTECTIVE EQUIPMENT (SEE CONTROL MEASURES).
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.24
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE MASTIC PASTE WITH NO STRONG ODOR
Percent Volatiles by Volume:30-40
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND CAUSTICS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:NORMAL COMBUSTION PRODUCTS, I.E. CO*X,
NO*X
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARDED SPILL RESIDUE MAY BE INCINERATED. DO
NOT INCINERATE SEALED CONTAINERS. DISPOSE I/A/W FEDERAL, STATE AND
LOCAL REGULATIONS. LIQUIDS CANNOT BE DISPOSED OF IN A LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ZE-4B ZYGLO EMULSIFIER
Preparer's Name:BRUCE C. GRAHAM
CAGE:37676
CAGE:37676
============= Composition/Information on Ingredients =============
Ingred Name:DISTILLATES (PETROLEUM),HYDROTREATED HEAVY NAPHTHENIC
CAS:64742-52-5
RTECS #:PY8035000
Fraction by Wt: >60.0%
Ingred Name:TERPINEOL,ALPHA-
CAS:98-55-5
RTECS #:WZ6700000
Fraction by Wt: 10.0%
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:ACUTE:MAY IRRITATE EYES.SEE
OVEREXPOSURE SYMPTOMS.
Effects of Overexposure:INHALATION:NOT LISTED BY
MANUFACTURER.HOWEVER,FINE SPRAY/MIST MAY CAUSE IRRITATION TO
BREATHING PASSAGES; EYES:LIQUID/MIST CAUSES IRRITATION;
SKIN:PROLONGED OR REPEATED CONTACT CAUSES IRRITATION BY DI SSOLVING
SKIN OILS; INGESTION:NOT NOTEDBY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY THE MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR; SKIN:REMOVE CONTAMINATED
CLOTHES.WASH OFF PROMPTLY WITH SOAP AND WATER.USE SOOTHING
LOTION.GET MEDICAL HELP IF IRRITATION PERSISTS; EYES:IMMEDIATELY
RINSE EYES WITH COP IOUS AMOUNT OF WATER.GET MEDICAL ASSISTANCE IF
IRRITATION PERSISTS; INGESTION:NOT STATED BY MANUFACTURER.GET
MEDICAL ATTENTION IF INGESTED.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F/>93C
Lower Limits:6.0
Upper Limits:1.0
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:WHEN INVOLVE IN COMBUSTION,MAY EMIT TOXIC
GASES AT OR ABOVE DECOMPOSITION TEMPERATURE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.SM QTY:WIPE UP OR MOP
UP BUT DO NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUMS; LG
QTY:WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA FAR AHEAD.ABSORB
LIQUID WITH COMMERCIAL ABSORBEN T.TRANSFER WASTE MATL IN SALVAGE
TANKS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA.AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS.KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS.DO NOT SMOKE WHILE USING.DO NOT
HEAT ABOVE 130F(54C).AVOID FREQUENT OR PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR FOR CONFINED
AREAS.
Ventilation:GENERAL ROOM VENTILATION TO KEEP BELOW TLV LIMITS.
Other Protective Equipment:NOT KNOWN
Work Hygienic Practices:WASH OFF PROMPTLY WITH WATER.AVOID SKIN
CONTACT.
Supplemental Safety and Health
NSN IS FOR TYPE II,METHOD B OF MIL-I-25135D;THIS ENTRY DESCRIBES ZE-4B
EMULSIFIER AS SINGLE ITEM OF TYPE II,METH B;ZE-4B ALSO GOES WITH
SKL-LO PENETRANT AS A PART OF KIT UNDER ABOVE TYPE/METHOD;QPL-25
135-15 ALSO QUALIFIED THIS PRODUCT TO GO WITH SEVERAL OTHER
PENETRANTS IN VARIOUS KITS OF TY I,METH A/B/C/D&LVL 1/2/3/4.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:410F/210C
Vapor Pres:0.25 @100F
Vapor Density:>1.0
Spec Gravity:0.92
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PINK OILY LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT KNOWN
Stability Condition to Avoid:HEAT,HIGH TEMPERATURES
Hazardous Decomposition Products:EMITS OXIDES OF CARBON WHEN BURNING.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF AS EPA HAZARDOUS WASTE
D001 (IGNITABLE WASTE),IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL,STATE,LOCAL REGULATIONS;IF LOCAL AUTHORITIES PROHIBIT
DUMPING RINSINGS DOWN THE SEWER,P URIFY RINSINGS WITH MAGNAFLUX
WASTEWATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RM 698 REPAIR MORTAR-HARDENER
Kit Part:Y
Preparer's Name:KEITH SANFORD/ (SUPDAT)
CAGE:11239
CAGE:11239
============= Composition/Information on Ingredients =============
Ingred Name:4,4'-ISOPROPYLIDENEDIPHENOL (SARA III)
CAS:80-05-7
RTECS #:SL6300000
Ingred Name:BENZYL ALCOHOL
CAS:100-51-6
RTECS #:DN3150000
Ingred Name:MIXED 2,2,4 AND 2,4,4-TRIMETHYL-1,6-; HEXANEDIAMINE ISOMERS
CAS:25513-64-8
Ingred Name:TRIMETHYLHEXANEDIAMINE ISOMERS REACTED WITH DIGLYCIDYL
ETHER OF BISPHENOL A
CAS:68845-20-5
Ingred Name:CYCLOHEXANEMETHYL AMINE, 5-AMINO-1, 3,3-TRIMETHYL-;
(ISOPHORONEDIAMINE)
CAS:2855-13-2
RTECS #:GV6129000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORROSIVE - CAUSES SKIN & EYE BURNS.
CAN BE ABSORBED THROUGH SKIN. SENSITIZER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SKIN & EYE BURNS. CAN CAUSE ALLERGIC REACTIONS
IN SUSCEPTIBLE INDIVIDUALS. ABSORPTION THROUGH SKIN CAN CAUSE
NAUSEA, VOMIT OR OTHER SIGNS OF ILLNESS.
Medical Cond Aggravated by Exposure:EYE, SKIN & RESPIRATORY CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/H20 FOR @ LST 15 MIN. CALL MD. SKIN:WASH
W/SOAP & H20. REMOVE CONTAM CLTHG & LAUNDER BEFORE REUSE.
INHAL:MOVE VICTIM TO FRESH AIR. GIVE O2 &/OR ARTF RESP, IF NEEDED.
CALL MD. INGEST :IF CONSCIOUS, GIVE PLENTY OF H20 TO DRINK. SEE MD.
DO NOT INDUCE VOMIT UNLESS DIRECTED TO BY MD. OTHER:REFERRAL TO MD
IS RECOMMENDED IF THERE IS ANY QUESTION ABOUT SERIOUSNESS OF
INJURY/EXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION & COMBUSTION
PRODUCTS CAN BE FORMED.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SPILLAGE WITH ABSORBENT MATERIAL &
DISPOSE I/A/W FEDERAL, STATE & LOCAL REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET IN EYES, ON SKIN, ON
CLOTHING. AVOID BREATHING VAPOR/MIST. KEEP CONTAINER CLOSED. USE
WITH ADEQUATE VENTILATION.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED ORGANIC VAPOR CARTRIDGE
RESPIRATOR WHEN AIR MOVEMENT IS INADEQUATE. NEVER ENTER CONFINED
SPACE W/ OUT A NIOSH/MSHA AIR-SUPPLIED RESPIRATOR/SCBA.
Ventilation:GEN(I.E. NATRL/MECH INDUCED FRESH AIR MOVEMENTS THAT MAINT
VAP CONC BELOW RECOMMENDED EXPOS LIMITS).
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PREPARER'S NAME:STEVE GERRARD.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR AMBER LIQUID, WITH AMMONIA-LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING ACIDS, LEWIS ACIDS, METAL ORGANICS, NATURAL RUBBER.
Stability Condition to Avoid:EXCESSIVE HEAT FOR PROLONGED PERIODS OF
TIME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION CAN YIELD CO &
CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT W/REGULATORY AGENCIES OR CORPORATE
PERSONNEL FOR DISPOSAL METHODS THAT COMPLY W/LOCAL, STATE & FEDERAL
HEALTH & ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CLEANING COMPOUND SOLVENT
CAGE:ASAHI
CAGE:ASAHI
============= Composition/Information on Ingredients =============
Ingred Name:1,1,2-TRICHLORO-1,2,2-TRIFLUOROETHANE; (CC1*2FCC1F*2)
(SARA III)
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: 99.9%
OSHA PEL:1000PPM;1250PPM STEL
ACGIH TLV:1000PPM;1250PPM STEL
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION OF VAPOR PRODUCES ILL
EFFECTS ON THE NERVOUS SYSTEMS AND MUCOUS MEMBRANES. IT CAUSES
SEVERE SKIN DRYNESS AND CRACKING. TOXICITY IS LOW.
CHLOROFLUOROCARBON (CFC) MATLS HAVE PRDCED SENSITIZAT ION OF
MYOCARDIUM TO EPINEPHRINE IN LABANIMALS & MAY HAVE A SIMILAR EFFECT
IN HUMANS. ADRENOMIMETICS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: (I.E., EPINEPHRINE) MAY BE CONTRA-
INDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS ACUTELY OR
CHRONICALLY EXPOSED TO CHLOROFLUOROCARBON .
Medical Cond Aggravated by Exposure:LARYNGITIS, PULMONARY EDEMA,
COUGHING.
======================= First Aid Measures =======================
First Aid:INGEST: FEED BREAD SOAKED IN MILK, RICE, GRUEL; TOXICITY IS
LOW. INHAL: REMOVE TO FRESH AIR. EYES: RINSE WITH PLENTY OF WATER
FOR A MINIMUM OF 15 MINUTES. SKIN: WASH WITH SOAP & WATER UNTIL ALL
TRACES OF PRODUCT ARE REMOVED.
===================== Fire Fighting Measures =====================
Flash Point:NON FLAMMABLE
Extinguishing Media:ALL EXTINGUISHING MEDIA ARE SUITABLE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE. THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE FLUORIDES, CHLORIDES, AND PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:SOLVENT DRIES VERY QUICKLY - ABOUT 70 TIMES
FASTER THAN WATER. SPILLED MATERIAL WILL DISSOLVE DIRT, OILS AND
FATS AND WILL EVAPORATE QUICKLY. COVER RESIDUALS W/CARBONATES OR
BICARBONATES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY WELL VENTILATED
AREA. USE NORMAL HANDLING PRECAUTIONS. USE A PUMP FOR TAKING LIQUID
OUT OF THE DRUM.
Other Precautions:IF VESSEL CNTNG SOLV HAS BEEN MISTAKENLY SUBJECTED TO
HEAT, CHECK TO SEE WHETHER THE PH IS 5.0 MIN. BEFORE USING. NO SMKG
IN AREA OF USE. DO NOT USE IN GEN VICINITY OF ARC WELDING/OPEN
FLAMES/HOT SURF . HEAT &/OR UV RADIATION MAY (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:MECHANICAL (GENERAL): USE FOR GENERAL AREA CONTROL.
Other Protective Equipment:BOOTS AND APRON SHOULD BE USED WHEN
NECESSARY.
Work Hygienic Practices:KEEP WORK AREA CLEAN.
Supplemental Safety and Health
OTHER PREC: CAUSE THE FORMATION OF CHLORIDES, FLUORIDES OR PHOSGENE .
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:118F,48C
Vapor Pres:272 @ 20C
Vapor Density:6.46
Spec Gravity:1.572 @ 20C
Evaporation Rate & Reference:123 (ETHER=100)
Solubility in Water:0.017/100 (25C)
Appearance and Odor:COLORLESS, CLEAN LIQUID, NEARLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
PLASTICS.
Stability Condition to Avoid:EXPOSURE TO EXTRAORDINARILY HIGH
TEMPERATURES.
Hazardous Decomposition Products:HYDROCHLORIC ACID, HYDROFLUORIC ACID.
PHOSGENE .
==================== Disposal Considerations ====================
Waste Disposal Methods:SHOVEL INTO SUITABLE CONTAINER AND DISPOSE IN AN
APPROVED CHEMICAL LANDFILL. DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ASHLAND CATALYST 65-018
CAGE:5A188
CAGE:5A188
============= Composition/Information on Ingredients =============
Ingred Name:4-(3-PHENYLPROPYL) PYRIDINE *93-1*
CAS:2057-49-0
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INHALATION:
NASAL & RESPIRATORY IRRITATION. INGESTION: GASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING & DIARRHEA.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER.
INGESTION: DRINK 2 GLASSES OF WATER & INDUCE VOMITING BY EITHER
GIVING IPECAC SYRUP OR BY PLACING FINGER AT BACK OF THROAT. NEVER
GIVE ANYTHIN G BY MOUTH TO AN UNCONSCIOUS PERSON. INHALATION:
REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, ADMINISTER OXYGEN.
IF BREATHING HAS STOPPED GIVE ARTIFICIAL RESPIRATION. OBTAIN MED
ATTN IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:276F/135.6C
Extinguishing Media:REGULAR FOAM OR WATER FOG, CO2 OR DRY CHEMICAL
Fire Fighting Procedures:USE SCBA W/A FULL FACEPIECE OPERATED IN THE
POSITIVE PRESSURE MODE. WATER/FOAM MAY CAUSE FROTHING.
Unusual Fire/Explosion Hazard:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUM (EVEN EMPTY) BECAUSE PRODUCT (EVEN JUST RESIDUE) CAN
IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB LIQUID ON VERMICULITE, FLOOR ABSORBENT,
OR OTHER ABSORBENT MATERIAL & TRANSFER TO HOOD. LARGE SPILL:
EVACUATE AREA. STOP AT SOURCE. DIKE AREA, PUMP LIQUID TO SALVAGE
TANK. REMAINING LIQUID, TAK E UP ON ABSORBENT MATERIAL. SHOVEL
INTOCONTAINER.
======================Handling and Storage ======================
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES, ALL
HAZARD PRECAUTIONS GIVEN IN THE DATA SHEET MUST BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF OVEREXPOSURE HAS BEEN DETERMINED OR
DOCUMENTED, USE A NIOSH/MSHA JOINTLY APPROVED AIR SUPPLIED
RESPIRATOR IS ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL.
OSHA REGS ALSO PERMIT OTHER NIOSH/MS HA RESPIRATORS UNDER SPECIFIC
CONDITIONS
Ventilation:SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST) TO KEEP
BELOW TLV.
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
CON'T DISPOSAL: CONTAMINATED ABSORBENT MAY BE DEPOSITED IN A LANDFILL
IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:612F/322C
Vapor Pres:<0.10
Vapor Density:>1
Spec Gravity:1.024
Evaporation Rate & Reference:SLOWER THAN ETHER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG MINERAL ACIDS.
Hazardous Decomposition Products:CO2, CO, NITROGEN COMPOUNDS, VARIOUS
HYDROCARBONS, ETC.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL SPILL: ALLOW VOLATILE PORTION TO EVAPORATE
IN HOOD. PACKAGE REMAINING MATL IN PAPER & BURN IN AN INCINERATOR
IN ACCORDANCE W/APPLICABLE REGS. LARGE SPILL: DESTROY BY LIQUID
INCINERATION IN ACCOR DANCE W/APPLICABLE REGS. SEE SUPP.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:06445 BRAYCOTE ROH-2
CAGE:EO453
CAGE:EO453
DIV
CAGE:2R128
============= Composition/Information on Ingredients =============
Ingred Name:FLUOROCARBONS (TYPE NOT SPECIFIED)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION. INHALATION OF
DECOMPOSITION PRODUCT/SMOKE OF CONTAMINATED TOBACCO PRODUCTS MAY
CAUSE RESPIRATORY IRRITATION & INDUCE POLYMER FUME FEVER CONDITION.
MAY ALSO CAUSE LUNG IRRITATION , PULMONARY EDEMA. INGESTION:
CATHARSIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:LUNG IRRITATION, FLU-LIKE SYMPTOMS SUCH AS
FEVER & CHILLS. EYES: REDNESS. INGESTION: CATHARSIS & DIARRHEA.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WIPE OFF MATERIAL. WASH
THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/PLENTY WATER FOR AT LEAST
15 MINS. INGESTION: DON'T INDUCE VOMITING. GIVE 2 GLASSES OF WATER
W/CHAR COAL SLURRY OR PLAIN WATER. DON'T GIVE ANYTHING BY MOUTH IF
UNCONSCIOUS. INHALATION: REMOVE TO FRESH AIR. ADMINISTER OXYGEN IF
NECESSARY. OBTAIN MEDICAL ATTENTION IN ALL CASES. (SEE SUPPL.)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Fire Fighting Procedures:USE WATER FOG OR SPRAY TO COOL FIRE EXPOSED
CONTAINERS. WEAR SELF-CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:SCRAPE UP EXCESS GREASE & STORE IN CLOSED
CONTAINERS FOR DISPOSAL. CLEAN UP AREA W/APPROPRIATE CLEANER.
======================Handling and Storage ======================
Handling and Storage Precautions:MAINTAIN AMBIENT TEMPERATURES. KEEP
CONTAINER TIGHTLY CLOSED. DON'T STORE NEAR HEAT, FLAME, STRONG
OXIDANTS. MAINTAIN ADEQUATE VENTILATION.
Other Precautions:AVOID PROLONGED/REPEATED BREATHING OF
VAPORS/MISTS/FUMES. DON'T SMOKE/CARRY TOBACCO PRODUCTS NEAR
PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE
RESPIRATOR OR SUPPLIED AIR RESPIRATORY EQUIPMENT AS REQUIRED
Ventilation:EXHAUST IF TEMPERATURES EXPECTED TO EXCEED 300C
Other Protective Equipment:IMPERVIOUS GARMENTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. DON'T CONSUME FOOD, DRINK OR HANDLE TOBACCO PRODUCTS WHEN
USING.
Supplemental Safety and Health
FIRST AID (CONT'D): POLYMER FUME FEVER SYMPTOMS SHOULD SUBSIDE W/IN 24
HRS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:146-410F
Vapor Pres:0.001
Spec Gravity:1.9
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE COLORED GREASE, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACTIVE METALS, METAL OXIDES AT TEMPS >280C, LEWIS ACID CATALYSTS,
STRONG OR NON-AQUEOUS ALKALI, STRONG OXIDANTS
Stability Condition to Avoid:OPEN FLAME, TEMPS >300C, & OTHER IGNITION
SOURCES
Hazardous Decomposition Products:HYDROGEN FLUORIDE, CARBONYL FLUORIDE,
& OTHER ACID FLUORIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL RECOVERED MATERIAL SHOULD BE PACKAGED,
LABELLED, TRANSPORTED & DISPOSED OF OR RECLAIMED W/GOOD ENGINEERING
PRACTICES. DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T BURN MATE RIALS CONTAMINATED W/THIS PRODUCT.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SCS1297
Preparer's Name:G.C.D.
CAGE:01139
CAGE:01139
============= Composition/Information on Ingredients =============
Ingred Name:SILANE, METHYLTRIACETOXY-; (METHYLTRIACETOXYSILANE).
LD50:(ORAL,RAT)2060 MG/KG
CAS:4253-34-3
RTECS #:VV4500000
Fraction by Wt: 1-5%
OSHA PEL:10 PPM (MFR)
ACGIH TLV:10 PPM (MFR)
Ingred Name:POLYDIMETHYL SILOXANE, HYDROXY-TERMINATED; (SILANOL/STPD
POLYDIMETHYLSILOXANE (NON HAZARDOUS))
CAS:70131-67-8
Fraction by Wt: 60-80%
Ingred Name:TRADE SECRET COMPONENT (NON HAZARDOUS)
Fraction by Wt: 10-30%
Ingred Name:TRADE SECRET COMPONENT. (NON HAZARDOUS) LD50:(ORAL,RAT)3160
MG/KG
Fraction by Wt: 10-30%
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGEST: MAY BE HARMFUL IF
SWALLOWED. SKIN: UNCURED PRODUCT CONTACT WILL IRRITATE LIPS, GUMS
AND TONGUE. UNCURED PRODUCT CONTACT MAY IRRITATE SKIN. INHAL:
CAUSES MILD RESPIRATORY IRRITATION. EYE : UNCURED PRODUCT CONTACT
IRRITATES. OTHER: ACETIC ACID RELEASED DURING CURING. CHRONIC: NONE
KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:RESPIRATORY.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMED . SKIN: REMOVE COMPLETELY WITH A DRY
CLOTH OR PAPER TOWEL, BEFORE WASHING W/DETERGENT AND WATER. GET
MEDICAL ATTENTION IF IRRITATION PERSISTS. INHAL: REMOVE TO FRESH
AIR. S UPPORT BRTHG (GIVE O*2/ARTF RESP) . EYES: IMMEDIATELY FLUSH
WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES AND GET MEDICAL
ATTENTION. NOTES TO PHYS: NONE KNOWN.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>400F,>204C
Extinguishing Media:ALL STANDARD FIREFIGHTING MEDIA.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE, SCRAPE/SOAK UP IN AN INERT MATERIAL AND
PUT IN A CONTAINER FOR DISPOSAL. WASH WALKING SURFACES W/DETERGENT
AND WATER TO REDUCE SLIPPING HAZARD. WEAR PROPER NIOSH/MSHA
APPROVED PROTECTIVE EQUIPME NT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/EYES/SKIN. CAUTION!
REMOVE CONT LENSES BEFORE USING SEALANT. UNCURED PROD CONT
IRRITATES EYES, & MAY IRRITATE SKIN.
Other Precautions:DO NOT HANDLE LENSES UNTIL ALL SEALANT HAS BEEN
CLEANED FROM FINGERTIPS, NAILS & CUTICLES. RESIDUAL SEALANT MAY
REMAIN ON FINGERS FOR SEVERAL DAYS & TRANSFER TO LENSES & CAN CAUSE
SEV EYE IRRIT. USE M ECH VENT TO STAY BELOW TLV OF(SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE IN A WELL VENTILATED AREA. USE NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:USE ONLY IN WELL VENTILATED AREA. MECHANICAL VENTILATION.
LOCALIZED VENT SHOULD BE USED TO CONTROL DUST LEVELS.
Other Protective Equipment:EYE WASH STATIONS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PREC: 10 PPM ACETIC ACID. USE IN A WELL VENTILATED AREA TO
PREVENT IRRITATION BY VAPORS.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:NEGLIGIBLE
Vapor Density:NEGLIGIBLE
Spec Gravity:1.07(H*2O=1)
Evaporation Rate & Reference:<1(BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK SOLID, ACETIC ACID
Percent Volatiles by Volume:<5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SILICON DIOXIDE, ACETIC ACID.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:REFLECTIONS
CAGE:52601
CAGE:52601
============= Composition/Information on Ingredients =============
Ingred Name:1,2-PROPYLENE GLYCOL 1-PROPYL ETHER
CAS:1569-01-3
RTECS #:UB9351000
= Wt:5.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Health Hazards Acute and Chronic:EYES: MAY CAUSE IRRITATION/INJURY.
SKIN: IRRITATION, REPEATED CONTACT MAY CAUSE DERMATITIS. INGESTION:
IRRITATION TO MOUTH, THROAT & STOMACH. SWALLOWING GLYCOL ETHERS MAY
INJURE LIVER & KIDNEYS. INHAL ATION: RESPIRATORY TRACT IRRITATION.
Effects of Overexposure:IRRITATION, HEADACHE, NAUSEA, DIZZINESS,
UNCONSCIOUSNESS
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER. CONTINUE RINSING
FOR 15 MINS. SKIN: RINSE THOROUGHLY W/COOL WATER. INGESTION: DILUTE
W/1-2 CUPS OF WATER/MILK. INHALATION: IMMEDIATELY MOVE TO FRESH
AIR.
===================== Fire Fighting Measures =====================
Flash Point:=97.8C, 208.F
Extinguishing Media:FOAM, WATER, FOG, DRY CHEMICAL & CO2
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE IGNITION SOURCES.
COLLECT W/ABSORBENT MATERIAL/MECHANICAL DEVICE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR IF USAGE
CONDITIONS REQUIRE RESPIRATORY PROTECTION.
Ventilation:MECHANICAL VENTILATION IS ADEQUATE.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
HAVE EYES EXAMINED & TESTED BY MEDICAL PERSONNEL.
================== Physical/Chemical Properties ==================
Boiling Pt:=98.9C, 210.F
Melt/Freeze Pt:=3.9C, 39.F
Spec Gravity:0.98
pH:6-8
Solubility in Water:APPRECIABLE
Appearance and Odor:CLEAR PURPLE COLOR LIQUID W/PLEASANT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, OXIDES OF NITROGEN MAY FORM WHEN
BURNED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:NOT A DOT HAZARDOUS MATERIAL.
===================== Regulatory Information =====================
State Regulatory Information:NO INFORMATION AVAILABLE.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VELCRO FR-127 5 GALLON
Preparer's Name:D.C. MOLBERG
CAGE:60775
CAGE:60775
CAGE:70707
============= Composition/Information on Ingredients =============
Ingred Name:ING 8: CAUSES IRRITATION. CAUSES POSSIBLY IRREVERSIBLE EYE
BURNS. CHRONIC: LONG TERM OVEREXPOS TO SOLVENTS IN (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:PROD HAS BEEN ASSOCD W/CNS PROBLEMS & KIDNEY & LIVER
DAM. TARGET ORGANS:SKIN, EYE, LIVER, KIDNEY, CNS.
RTECS #:9999999ZZ
Ingred Name:METHANE, DICHLORO-; (METHYLENE CHLORIDE, DICHLOROMETHANE)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 15.5%
OSHA PEL:500 PPM; 1000, C
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CARBON TETRACHLORIDE; (CARBON TET)
CAS:56-23-5
RTECS #:FG4900000
Fraction by Wt: 0.1%
OSHA PEL:10 PPM
ACGIH TLV:S,5PPM/10 STEL,A3 93
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ozone Depleting Chemical:1
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE, MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 43.9%
OSHA PEL:200 PPM;300 PPM STEL
ACGIH TLV:200 PPM;300 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:DGBA EPOXY RESINS; (DIGLYCIDYL ETHER RESIN WITH BISPHENOL
A)
CAS:25068-38-6
RTECS #:SL6475000
Fraction by Wt: 1.2%
Ingred Name:TOLUENE; (METHYL BENZENE) (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 15.6%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HLTH HAZ: TOLUENE CAS# 108-88-3 APPEARS ON THE NAVY LISTING
OF OCCUP REPRO HAZ. SEEK CONSULTATION FROM APPROP (ING 7)
RTECS #:9999999ZZ
Other REC Limits:YN/K SPECIFIED
Ingred Name:ING 6: HLTH PROFESSIONALS CONCERNING LATEST HAZARD LIST
INFO AND SAFE HANDLING & EXPOS RECOMMENDATIONS . (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: INGEST: HAZ IF INGESTED. ABSORPTION: NO HAZARD KNOWN
AT THIS TIME. INHAL: HAZ IF INHALED.EYE CONTACT: (ING 9)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL) 50-500 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CHLOROCARBON/CHLOROFLUOROCARBON (CFC)
MATLS HAVE PRDCED SENSIT OF THE MYOCARDIUM TO EPINEPHRINE IN LAB
ANIMALS & COULD HAVE SIMILAR EFT IN HUMANS. ADRENOMIMETICS (E.G.
EPINEPHRINE) MAY BE CONTRAINDICA TED EXCEPT FOR LIFE-SUSTAINING
USES IN HUMANS ACUTELY/CHRONICALLY EXPOSED TO CHLOROCARBONS/CFC'S .
(ING 6)
Explanation of Carcinogenicity:METHYLENE CHLORIDE:GRP 2B
(IARC),ANTICIPATED TO BE A CARCIN (NTP).CARBON TETRACHLORIDE:GRP 2B
(IARC), (SUPP DATA)
Effects of Overexposure:IRRITATION, DIZZINESS, WEAKNESS,
LIGHTHEADEDNESS, HEADACHE, NAUSEA, VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:NONE KNOWN TO BOSTIK.
======================= First Aid Measures =======================
First Aid:INGEST:IF SWALLOWED, CALL MD.THE ATTENDING MD MUST DECIDE
WHETHER OR NOT TO INDUCE VOMITING BASED ON HIS EVALUATION OF
PATIENT. INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG GIVE ARTF RESP,
PREF MOUTH TO M OUTH. IF BRTHG IS DIFFICULT GIVE O*2. CALL MD. EYE:
IN CASE OF CONTACT, IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT
LEAST 15 MINUTES. CALL MD. SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER.
CALL MD .
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:28.0F,-2.2C
Lower Limits:3.78%
Upper Limits:13.3%
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER. THERMAL
DECOMPOSITION PRODUCTS MAY INCLUDE HCL AND PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP LIQUID WITH AN ABSORBENT MATERIAL SUCH
AS SAND, EARTH, SWEEPING COMPOUND OR SOME OTHER ABSORBENT MATERIAL.
PACKAGE ABSORBENT MATERIAL OR SOLID PRODUCT IN STEEL DRUMS WHICH
ARE IN GOOD CONDITIO N. THOROUGHLY CLEAN AREA WHERE SPILL OCCURRED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL LOCATION (60-80F) AWAY
FROM SUNLIGHT & ANY SOURCE OF HEAT, SPKS/FLAME.KEEP CNTNR TIGHTLY
CLSD WHEN NOT BEING USED.USE W/ADEQ VENT.
Other Precautions:AVOID PRLNGD/RPTD BRTHG OF VAPS.AVOID SKIN CONT.USE
IN AREA FREE FROM FLAME & SPKS.NO SMOKING IN AREA OF USE.DO NOT USE
IN GEN VICINITY OF ARC WELDING, OPEN FLAMES/HOT SURFS.HEAT &/UV
RADIATION MAY CA USE FORMATION OF HCL &/PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST IS PREFERRED, MECHANICAL EXHAUST IS
ACCEPTABLE.
Other Protective Equipment:SAFETY SHOWER AND EYEBATH.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PROD:MAY INCLUDE CO*2/CO/H*2O VAP, NO*X/WIDE VARIETY OF
INNOCUOUS/TOX FUMES.HYDROGEN CHLORIDE/BROMIDE & CYANIDE WILL ALSO
BE PRDCD ALONG W/SM AMTS OF PHOSGENE.WASTE DISP METH:CLASSIFIED AS
HAZ WASTE UNDER FED REGS IN EFT @ TIME OF PRINTING OF THIS MSDS.
EXPLAN OF CARCIN: ANTICIPATED TO BE A CARCINOGEN (NTP).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>104F,>40C
Vapor Pres:126
Vapor Density:2.73
Spec Gravity:0.98
Evaporation Rate & Reference:6.7 (BUTYL ACETATE=1)
Solubility in Water:12%
Appearance and Odor:A STRAW COLORED LIQUID WITH A KETONE ODOR.
Percent Volatiles by Volume:82.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ACIDS OR ALKALIS, AMINES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:UNKNOWN DUE TO COMPLEX NATURE OF MATL.
FUMES FROM COMPLETE/INCOMPLETE COMBUST OF MATL (SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FED, STATE & LOC REGS.BE AWARE
THAT STATE & LOC REQMTS MAY DIFFER WIDELY DEPENDING ON LOCATION &
IN MANY CASES BE DIFFERENT FROM FED RULES. WHEN INTENDING TO
DISPOSE OF MATL, THE USER IS ADVISED THAT PROD WOULD BE (SUPP
DATA)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BX0870 BORIC ACID,POWDER ACS
CAGE:63612
CAGE:63612
CAGE:08474
============= Composition/Information on Ingredients =============
Ingred Name:BORIC ACID, ORTHOBORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 2660 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: HARMFUL. EYES: IRRITATION.
SKIN: IRRITATION, TOXIC ABSORPTION THROUGH WOUNDS OR MUCOUS
MEMBRANES. INGESTION: HARMFUL, GASTROINTESTINAL IRRITATION, NAUSEA,
VOMITING, DIARRHEA, CIRCULATORY F AILURE, COMA, FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION: KIDNEY & LIVER DAMAGE.
Medical Cond Aggravated by Exposure:SKIN DISORDERS OR EYE PROBLEMS,
IMPAIRED LIVER, KIDNEY, OR RESPIRATORY FUNCTION
======================= First Aid Measures =======================
First Aid:SKIN: IMMEDIATELY FLUSH THOROUGHLY W/LARGE AMOUNTS OF WATER.
EYES: IMMEDIATELY FLUSH THOROUGHLY W/WATER FOR AT LEAST 15 MINS.
INHALATION: REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF
BREATHING HAS STOPPED. INGESTION: IF CONSCIOUS, INDUCE VOMITING.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE ANY SUITABLE MEDIA FOR ADJACENT MATERIAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED, POSITIVE PRESSURE,
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:A MIXTURE OF BORIC ACID & POTASSIUM CAN
EXPLODE ON IMPACT.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP & CONTAINERIZE FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED TIGHTLY. DON'T
BREATHE DUST. AVOID CONTACT W/EYES, SKIN, OR CLOTHING. DON'T TAKE
INTERNALLY.
Other Precautions:MOISTURE CONTAMINATION CAN CAUSE BORIC ACID TO BE
CORROSIVE TO IRON.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA-APPROVED RESPIRATOR SHOULD BE WORN IN
THE ABSENCE OF ADEQUATE VENTILATION.
Ventilation:USE APPROVED FUME HOOD OR ADEQUATE VENTILATION WHEN
HANDLING OR TRANSFERRING MATERIAL.
Other Protective Equipment:EYE WASH & SAFETY EQUIPMENT
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:M.P/F.P Text:185C
Vapor Pres:2.6
Spec Gravity:1.435
Solubility in Water:5%
Appearance and Odor:WHITE POWDER OR GRANULES, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, POTASSIUM, ACETIC ANHYDRIDE, ALKALIES, CARBONATES, & HYDROXIDES
Stability Condition to Avoid:MOISTURE CONTAMINATION
Hazardous Decomposition Products:BORON OXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NIPOL NITRILE (NBR) ELASTOMERS, DN 214
CAGE:0J3F9
CAGE:0J3F9
============= Composition/Information on Ingredients =============
Ingred Name:ING 19:PROVIDED TO PREVENT SIGNIFICANT EMPLOYEE EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT:IN PROCESSING AREAS. DO NOT USE PROCESSING
EQUIPMENT TO HEAT FOOD.
RTECS #:9999999ZZ
Ingred Name:HAZ DECOMP PROD:ALIPHATIC HYDROCARBONS. COMBUST PRODS FROM
RUBBER, LIKE THOSE OF NATURAL & SYNTHETIC MATLS, MUST (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:BE CONSIDERED TOXIC.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:SYMPS SUCH AS COUGH, TEARING & IRRIT SHOULD
BE REGARDED AS POTNTLY HAZ & MEASURES TAKEN TO AVOID(ING 09)
RTECS #:9999999ZZ
Ingred Name:ING 08:EXPOSURE. MFR MONITORING/SIMULATION SHOWS EXPOSURE
TO INGS 1 & 2 TO BE LESS THAN OSHA WARNING (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 09:REQUIREMENTS OR EXPOSURE LIMITS. CONTACT NEHC FOR
MORE INFORMATION .
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:EXHST HOODS, DUCTWORK & OTHER SURFS. CLEAN UP
SHOULD BE PERFORMED UNDER WELL VENTILATED CNDTNS. (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:ELASTOMER MAY BE HELD AT PROCESS TEMPS FOR SHORT
TIME, BUT EXPOS TO ELEVATED TEMP/EXCESSIVE TIME WILL (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 14:RSLT IN DECOMP. EQUIP SHOULD NOT BE SHUT DOWN FOR
EXTENDED TIME PERIODS W/CMPD IN IT/DECOMP WILL OCCUR. (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 13:ABNORMAL CNDTNS SUCH AS EQUIP MALFUNCTION, IMPROPER
EQUIP/STAGNATION OF MATL DURING PROCESSING MAY CAUSE (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:DECOMP. EMPLOYEES REMOVING DECOMPOSING MATL SHOULD
BE PROVIDED SUITABLE NIOSH/MSHA APPRVD AIR-SUPPLIED (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:RESPIRATORS, SUCH AS POSITIVE PRESSURE SCBA. ALWAYS
AVOID INHALATION OF FUMES.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:HANGUP/STAGNATION DURING PROCESSING MAY CAUSE
DECOMP. IF GEN DILUTION/LOC EXHST VENT IS NOT ADEQ TO (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:AVOID EXPOS, PROVIDE EMPLOYEES W/SUITABLE NIOSH/MSHA
APPRVD AIR SUPPLIED RESPS, SUCH AS POS PRESS SCBA.
RTECS #:9999999ZZ
Ingred Name:VENT:MUST BE ADEQ TO MAINTAIN AMBIENT WORKPLACE ATM BELOW
LIMS LISTED IN INGS SECTION. LOC EXHST VENT SHOULD BE (ING 20)
RTECS #:9999999ZZ
Ingred Name:ACRYLONITRILE (SARA III)
CAS:107-13-1
RTECS #:AT5250000
Fraction by Wt: <20% PPM
OSHA PEL:2 PPM;10 PPM, C, S
ACGIH TLV:2 PPM, S
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:1,3-BUTADIENE; (BUTADIENE)(SARA III)
CAS:106-99-0
RTECS #:EI9275000
Fraction by Wt: <5% PPM
Other REC Limits:2 PPM;15 PPM, C(MFR)
OSHA PEL:1000 PPM
ACGIH TLV:10 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ACRYLONITRILE/BUTADIENE/POLYMER
CAS:9003-18-3
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:THIS REPRESENTS HAZ TO FIREFIGHTERS.
RTECS #:9999999ZZ
Ingred Name:MATLS TO AVOID:COMPOUNDS, ARE NOT COMPATIBLE W/THESE
ELASTOMERS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:OVEREXP IS NOT EXPECTED AT
AMBIENT TEMPS. NO ADVERSE HLTH EFTS ARE EXPECTED DURING NORMAL
PROCESSING WHEN POTNTL EXPOS ARE ELIM BY GOOD INDUS HYGIENE
PRACTICE & WELL VENTILATED CNDTNS. AT PROCES SING TEMPS, COMBINED
INGS (ELASTOMER & OTHER PROCESSING INGS) MAY EMIT FUMES & VAPS THAT
CAUSE IRRIT TO(EFTS OF OVEREXP)
Explanation of Carcinogenicity:ACRYLONITRILE AND BUTADIENE ARE PRESENT
AT CONCENTRATIONS BELOW REPORTABLE LEVELS .
Effects of Overexposure:HLTH HAZ:RESP TRACT, EYES &/OR SKIN. TYPICALLY,
THESE EFTS ARE REVERSIBLE UPON REMOVAL FROM EXPOS & NO LASTING EFTS
ARE EXPECTED. MOST IMPORTANTLY, POTNTL FOR IRRIT WILL DEPEND ON
EFTIVENESS OF EXHST VENT PROVIDED TO PROCESS AREA. OVEREXP TO
DECOMP/COMBUST PRODS WILL CAUSE IRRIT OF RESP TRACT, EYES & SKIN.
(ING 10)
Medical Cond Aggravated by Exposure:NONE KNOWN FOR PRODUCT AS
DELIVERED.
======================= First Aid Measures =======================
First Aid:IF IRRIT OCCURS/PERSISTS FROM ANY RTE OF EXPOS, REMOVE
AFFECTED INDIVIDUAL FROM AREA. CALL MD. PROVIDE PROT BEFORE
ALLOWING REENTRY. INGEST:CALL MD IMMED . EYE:FLUSH W/RUNNING WATER
FOR SEVERAL MINS (AT LEAST 15 MINS) WHILE HOLDING EYELIDS OPEN.
CONSULT MD IF IRRIT PERSISTS. SKIN:REMOVE CONTAM CLTHG. WASH W/SOAP
& WATER. INHAL:REMOVE AFFECTED INDIVIDUAL TO FRESH AIR. CONSULT MD
IMMED.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, ABC DRY CHEM/PROTEIN TYPE AIR FOAMS ARE REC
MEDIA. ELASTOMERS WOULD BE CONSIDERED "ORDINARY COMBUSTS" (SUPDAT)
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
PERS NOT PROTECTED MUST LEAVE AREA. IN ENCLSD/POORLY VENTILATED
AREAS, WEAR NIOSH/MSHA APPRVD SCBA (SUPDAT)
Unusual Fire/Explosion Hazard:MOST ORG SUBSTANCES IN FORM OF FINE
DUST/PWDR PRESENT EXPLO HAZ. TAKE PRECS IF THESE ELASTOMERS ARE
GROUND/OTHERWISE FORMED INTO FINE PWDR. HYDROGEN (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP, SHOVEL OR VACUUM CRUMBS OR CHUNKS INTO
CLOSED CONTAINERS FOR REUSE OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE AWAY FROM
DIRECT LIGHT TO MAINTAIN QUALITY. IT IS USERS RESPONSIBILITY TO
FOLLOW REC PRECS OF INDIVIDUAL ADDITIVE SUPPLIERS.
Other Precautions:ELASTOMERS EMIT FUMES & VAPS WHEN HEATED TO
PROCESSING TEMPS. ALWAYS PROCESS ELASTOMERS UNDER WELL VENTILATED
CNDTNS & AVOID CONTINUED/PRLNG BRTHG OF PROCESS VAPS. CONDENSATES
MAY BE COMBUST & SHOULD BE PERIODICALLY REMOVED FROM (ING 13)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS SUPPLIED, RESP PROT IS NOT TYPICALLY REQD
DURING NORMAL USE & HNDLG OPERATIONS. NIOSH/MSHA APPRVD RESP PROT
MAY BE NEEDED IF PROD IS GROUND INTO FINE PWDR/DUST. ABNORMAL
CNDTNS SUCH AS EQUIP MALFUN CTION, IMPROPER EQUIP/PROCS, OR (ING
19)
Ventilation:EFTIVE LOC EXHST VENT MUST ALWAYS BE PROVIDED TO DRAW
FUMES/VAPS AWAY FROM WORKERS TO PVNT ROUTINE INHAL. VENT (ING 21)
Other Protective Equipment:PROTECTIVE CLOTHING SHOULD BE WORN DURING
CLEANUP OPERATIONS TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH THORO AFTER PROCESSING CMPD, ESP BEFORE
EATING, SMOKING/USING TOILET FACILITIES. DO NOT STORE/CONSUME FOOD
(ING 23)
Supplemental Safety and Health
% VOLAT:<1 (WT) (WATER VAP). EXTING MEDIA:(NFPA DEFINED CLASS A).
CARBON DIOXIDE IS GENERALLY NOT REC FOR USE ON CLASS A FIRES AS
LACK OF COOLING CAPACITY MAY RSLT IN REIGNIT. FIRE FIGHT
PROC:DURING C LEANUP IMMED AFTER FIRE AS WELL AS DURING
FIREFIGHTING OPERATIONS. EXPLO HAZ:CYANIDE GAS IS FORMED UPON
COMBUST. (ING 4)
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:TAN TO BROWN SLAB W/MILD CHARACTERISTIC ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO SPECIFIC INFO IS AVAIL, HOWEVER STRONG OXIDIZERS/REDUCING AGENTS
WHICH ARE GENERALLY NOT COMPAT W/MANY ORG (ING 5)
Stability Condition to Avoid:OVERHEATING.
Hazardous Decomposition Products:FUMES PRDCD WHEN HEATED TO DECOMP
TEMPS MAY CONTAIN:OXIDES OF CARBON, HYDROGEN CYANIDE & SM AMTS OF
AROMATIC & (ING 6)
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL OR INCINERATION I/A/W FEDERAL, STATE &
LOCAL REGULATIONS. THESE PRODUCTS ARE NOT DEFINED OR DESIGNATED AS
HAZARDOUS BY CURRENT PROVISIONS OF THE FEDERAL (EPA) RCRA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EMBEGUARD TX CHARCOAL GRAY
CAGE:98898
CAGE:98898
============= Composition/Information on Ingredients =============
Ingred Name:POLYOXYPROPYLENE DIAMINE (ALIPHATIC ETHER AMINE)*93-1*
CAS:9046-10-0
Fraction by Wt: 30-60%
Ingred Name:AMINOETHYL PIPERAZINE, 1-PIPERAZINEETHANAMINE
CAS:140-31-8
RTECS #:TK8050000
Fraction by Wt: 1-10%
Ingred Name:NONYL PHENOL
CAS:25154-52-3
RTECS #:SM5600000
Fraction by Wt: 10-30%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 5000 MG/KG SEE SUPP
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TEMPORARY OR MINOR INJURY MAY OCCUR.
EYES: IRRITATION W/CORNEAL INJURY. SKIN: IRRITATION, ABSORPTION IN
HARMFUL AMOUNTS IS POSSIBLE. INGESTION: GASTROINTESTINAL
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: POSSIBLE BURNS. INGESTION: NAUSEA,
VOMITING, DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/PLENTY OF
WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER. INGESTION: DON'T
INDUCE VOMITING. GIVE PLENTY OF WATER & AT LEAST ONE OUNCE OF
VINEGAR IN WATER. DON'T GIVE ANYTHING BY MOUTH IF UNCONSCIOUS.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>95C, 200F
Extinguishing Media:DRY CHEMICAL, FOAM OR CO2
Fire Fighting Procedures:WATER MAY BE USED TO KEEP FIRE-EXPOSED
CONTAINERS COOL.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP OR ABSORB ON SUITABLE MATERIAL &
SHOVEL UP.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR IF VAPOR LEVELS
EXCEED LIMITS GIVEN
Ventilation:MECHANICAL MUST BE PROVIDED TO MAINTAIN VAPOR LEVELS BELOW
TLV LIMITS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
LD50 INFORMATION IS FOR POLYOXYPROPYLENEDIAMINE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>260C
Vapor Density:>1
Spec Gravity:0.97
Solubility in Water:85%
Appearance and Odor:PALE YELLOW LIQUID W/AMMONICAL ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS
Stability Condition to Avoid:HIGH TEMPERATURES & PRESSURES. MAY REACT
W/WATER, BUT WILL NOT REALEASE ENERGY VIOLENTLY.
Hazardous Decomposition Products:CO, CO2 & AMMONIA
==================== Disposal Considerations ====================
Waste Disposal Methods:LIQUID INCINERATION OR APPROVED CHEMICAL
DISPOSAL AREA IN ACCORDANCE W/FEDERAL, STATE, & LOCAL REGULATIONS.
CORROSIVE LIQUID. UN1760. CONTAINERS OF THESE MATERIALS MAY BE
HAZARDOUS WHEN EMPTIED DUE TO PRODUCT RESIDUES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:121200, AGM TACTOO GPA-72 HIGH-TEMPERATUE(SUPDAT)
CAGE:77359
CAGE:77359
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III). VP:22 MM HG @ 20 DEG C.
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 60%
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC COMPOUNDS:5.10 LB/GAL LESS WATER & NPRS.
612 G/L LESS WATER CALCULATED
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUNDS:17.55 LB/GAL SOLIDS. 2106 G/L
SOLIDS CALCULATED.
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:CAUSE KIDNEY, LUNG & SPLEEN DMG IN LAB ANIMALS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:SKIN:REMOVE CONTAMD CLTHG. WASH AFFECTED
AREA W/SOAP & WATER. OBTAIN MED ATTN IF IRRIT PERSISTS. (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:NOTES TO PHYS:ANY TREATMENT THAT MIGHT BE REQD FOR
OVEREXP SHOULD BE DIRECTED @ CONTROL OF SYMP & CLINICAL CNDTNS.
RTECS #:9999999ZZ
Ingred Name:SPILL RELEASE:ABSORB. USE ONLY NON-SPARKING TOOLS. PLACE
ABSORB DIKING MATLS IN COVERED METAL CNTNRS FOR DISP. (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:PVNT CONTAM OF SEWERS, STREAMS, & GROUNDWATER
W/SPILLED MATLS OR USED ABSORBENT.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:SPRAYING, A MECH PREFILTER MAY ALSO BE REQD. IN
CONFINED AREAS NIOSH/MSHA APPRVD AIR SUPPLIED RESP. (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:IF TLV'S ARE EXCEEDED USE PROPERLY FITTED NIOSH/MSHA
APPRVD RESP W/AN APPROP PROT FACTOR. REFER TO OSHA (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:29CFR 1910.134 "RESP PROT" & "RESP PROT A MANUAL AND
GUIDELINE, AMERICAN INDUST HYGIENE ASSOC.
RTECS #:9999999ZZ
Ingred Name:VENT:PERMISSIBLE EXPOS LIM WHICH MAY BE LISTED IN INGREDS.
REFER TO INDUST VENT. A MANUAL FOR REC PRATICE - (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL
HYGIENISTS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOLUENE APPEARS ON THE NAVY LISTING OF
OCCUP CHEM REPROD HAZARDS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZARD LIST INFO & SAFE HNDLG &
EXPOS INFO . ACUTE:INGEST:CAN CAUSE GI IRRIT, NAUS, & VOMIT. ASPIR
OF MATL INTO LUNG MAY CAUSE CHEM PNEUM WHICH CAN BE FATAL. (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:INHAL:MAY CAUSE NOSE/THROAT IRRIT.
HIGH CONC MAY CAUSE ACUTE CNS DEPRESS CHARACTERIZED BY HDCH, DIZZ,
NAUS & CONFUSN. EYE:MAY CAUSE IRRIT. SKIN:MAY CAUSE DEFAT & IRRIT.
RPTD OVEREXP TO TOLUEN E MAY CAUSE LIVER DMG. RPTS HAVE ASSOC
PRLNGD & RPTD OCCUP OVEREXP TO SOLV W/PERM BRAIN & NERV SYS DAMG.
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INDUCE VOMIT. CALL POIS CTL CTR, HOSPITAL EMER
ROOM/PHYS IMMED. INHAL:REMOVE TO FRESH AIR IMMED. IF BRTHG HAS
STOPPED GIVE ARTF RESP. KEEP WARM & QUIET. GET MED ATTN IMMED.
EYE:FLUSH W/L G AMTS OF WATER, LIFTING UPPER & LOWER LIDS OCCASNLY.
CONTINUE @ LEAST 15 MINS. GET MED ATTN. SKIN:REMOVE CONTAMD CLTHG.
WASH AFFECTED AREA W/SOAP & WATER. OBTAIN MED ATTN IF IRRIT
PERSISTS. (ING 5)
===================== Fire Fighting Measures =====================
Flash Point:40.0F,4.4C
Lower Limits:1.7
Upper Limits:7.1
Extinguishing Media:USE NFPA CLASS B FIRE EXTINGUISHERS (CO*2, ALL
PURPOSE DRY CHEM/ALCOHOL FOAM) DESIGNED TO EXTING FLAMM LIQ
(SUPDAT)
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
WATER MAY BE INEFTIVE, BUT MAY BE USED TO COOL EXPOS CNTNRS TO PVNT
PRESS BUILD-UP & POSS AUTO-IGNIT (SUPDAT)
Unusual Fire/Explosion Hazard:DURING EMER CNDTNS, OVEREXP TO DECOMP
PROD MAY CAUSE HLTH HAZ. SYMP MAY NOT BE IMMED APPARENT. OBTAIN MED
ATTN. WARNING! FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. ELIM ALL IGNIT SOURCES
(FLAMES, HOT SURF, & SOURCES OF ELEC, STATIC/FRICTIONAL SPARKS).
DIKE & CONTAIN SPILL W/INERT MATL (E.G. SEND EARTH). TRANSFER LIQ
TO COVERED METAL CNTNRS FOR RECOVERY/DISP, OR REMOVE W/INERT (ING
7)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 115F (46C). STORE
LG QTYS IN COMPLIANCE W/OSHA 29CF4 1910.106. DO NOT TAKE
INTERNALLY. CLOSE CNTNR AFTER EACH USE.
Other Precautions:EMPTY CNTNRS MUST NOT BE WASHED & RE-USED FOR ANY
PURPOSE. CNTNRS SHOULD BE GROUNDED & BONDED TO RECEIVING CNTNR. DO
NOT WELD, BRAZE/CUT ON EMPTY CNTNR. NEVER USE PRESS TO EMPTY. DRUM
IS NOT A PRESS V ESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN GEN EXPOS TO ORG CHEM SUCH AS THOSE CONTAINED
IN THIS PROD MAY NOT REQ USE OF RESP PROT IF USED IN WELL
VENTILATED AREA. IN RESTRICTED VENT AREAS NIOSH/MSHA PPRVD CHEM
CARTRIDGE RESP MAY BE REQD. U NDER CERTAIN CNDTNS, SUCH AS (ING 9)
Ventilation:PROVIDE LOC EXHAUST VENT IN SUFFICIENT VOLUME & PATTERN SO
AS TO MAINTAIN EXPOS BELOW NUSIANCE DUST LIM & (ING 12)
Other Protective Equipment:NOT LIKELY TO BE NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:CONSTRUCTION ADHESIVE. EXTING MEDIA:FIRES.
POLYMER FOAM IS PREF FOR LG FIRES. FIRE FIGHT PREC:OR EXPLOSION
WHEN EXPOS TO EXTREME HEAT. IF WATER IS USED, FOG NOZZ ARE PREF.
EFTS OF OVERESP:INTENTIONAL MISUSE BY DELIB CONC & INHAL CONTENTS
MAY BE HARMFUL/FATAL. TOLUENE HAS BEEN FOUND TO (ING 4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:231F,111C
Vapor Density:HVR/AIR
Spec Gravity:1.0
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F (46C) AND
SOURCES OF IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE & CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FED, STATE & LOCAL LAWS. INCIN
ONLY IN EPA PERMITTED FACILITY. DO NOT INCIN CLSD CNTNRS. OBSERVE
PRECAUT FOR DISP OF FLAMM MATLS. CONTAMD ABSORB MAY BE DISPOSED IN
HAZ WASTE LANDFILL. DI SPOSE ONLY I/A/W FED, STATE & LOCAL REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-85285B, 11136, TYPE 1, 03R064
Kit Part:Y
Preparer's Name:NORM GAUL
CAGE:5M511
CAGE:33461
CAGE:5M511
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (CERCLA) (VAPOR PRESSURE 13 MM HG @ 68F)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM;STEL 200 PPM
ACGIH TLV:150 PPM;STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE (VAPOR PRESSURE 0.7 MM HG @ 68F)
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 10%
Other REC Limits:50 PPM; STEL 100 PPM
Ingred Name:ANTISETTLING AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TOLUENE (SARA III) (CERCLA) (VAPOR PRESSURE 22 MM HG @ 68F)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 3.3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DISPERSION AID (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:XYLENE (SARA 313) (CERCLA) (VAPOR PRESSURE 21 MM HG @ 100F)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0.34%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ANTI-FLOAT AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:FLOW AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHYL N-AMYL KETONE (VAPOR PRESSURE 2.1 MM HG @ 68F)
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
Ingred Name:ANTI MAR AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL BENZENE (SARA 313) (VAPOR PRESSURE 7.1 MM HG @ 68F)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 0.09%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 125 PPM
ACGIH TLV:100 PPM;STEL 125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:FLOW AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIBUTYLTIN DILAURATE (VAPOR PRESSURE 0.2 MM HG @ 320F)
CAS:77-58-7
RTECS #:WH7000000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:0.1 MG/M3
Ingred Name:2-4 PENTANEDIONE (VAPOR PRESSURE 6.9 MM HG @ 68F)
CAS:123-54-6
RTECS #:SA1925000
Fraction by Wt: <5%
Other REC Limits:UNION CARBIDE:20 PPM
Ingred Name:VOC: 330 G/L
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: RESP TRACT IRRIT & ACUTE
NERVOUS SYSTEM DEPRESSION
(HEADACHE,DIZZINESS,STAGGERING,CONFUSION,UNCONSCIOUSNESS,COMA).
SKIN: IRRIT (SWELLING,REDNESS,RASH). ABSORPTION:IRRIT,DRYING,DEFAT.
EYE:IRRIT (TEARING,REDNESS,SWELLING W/STING).INGEST:IRRIT,
CORROSIVE IN GI TRACT. VOMIT MAY CAUSE ASPIRATION--CHEM
PNEUMONITIS.
Effects of Overexposure:ACUTE: EYES, NOSE, THROAT IRRITATION.
INHALATION: HEADACHE, DIFFICULT BREATHING, UNCONSCIOUSNESS.
CHRONIC: PROLONGED CONTACT WILL CAUSE DRYING & CRACKING OF SKIN,
DUE TO DEFATTING ACTION. SKIN SENSITI ZATION, ASTHMA OR OTHER
ALLERGIC RESPONSES MAY DEVELOP.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA AND DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. RESTORE BREATHING. ASTHMATIC
TYPE SYMPTOMS MAY DEVELOP (IMMEDIATE OR DELAYED BY SEVERAL HOURS).
GET MEDICAL AID. SKIN: REMOVE CONTAMINATED CLOTHING. WASH AFFECTED
AREAS WITH SOAP & WATER. EYES: FLUSH WITH LUKEWARM WATER (LOW
PRESSURE) 15 MIN, LIFTING EYELIDS. GET MEDICAL AID. INGESTION: DO
NOT INDUCE VOMITING. NOTHING BY MOUTH TO UNCONSCIOUS PERSON. GET
MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:45.0F,7.2C
Lower Limits:1
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG,
WATER SPRAY
Fire Fighting Procedures:WEAR FULL FIRE FIGHTING EQUIP W/SCBA & FULL
PROTECTIVE CLOTHING. USE WATER TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD-UP, AUTO IGNITION, OR EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. KEEP FROM HEAT/IGNIT
SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT. APPLIC TO HOT SURFACE REQ
SPECIAL PRECAUTION. OVEREXPOSURE TO DECOMP PROD-HLTH HZD.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION. VENTILATE AREA. CONTAIN AND REMOVE WITH
INERT ABSORBENT AND NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN BLDGS IN COMPLY W/OSHA
1910.106,IN VENTD AREA,IN CLOSED CONTAINER.DON'T STORE NEAR HIGH
TEMP/IGNIT SOURCES.PREVENT PROLONGED BREATHING VAPOR.
Other Precautions:KEEP CONTAINERS TIGHT & UPRIGHT TO PREVENT LEAKING.
PROLONGED OVEREXPOSURE MAY CAUSE ALLERGIC REACTION. AVOID SKIN &
EYE CONTACT. DON'T INGEST. DON'T HANDLE TILL MANUFACTURER'S
PRECAUTIONS READ/UNDERS TOOD. SMOKE IN SMOKING AREAS ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR RECOMMENDED FOR ORGANIC VAPOR
ENVIRONMENT (AIR PURIFYING/FRESH AIR SUPPLIED) OBEY OSHA REGS FOR
RSPRTR USE. VENT TO KEEP BELOW OSHA PERMISSIBLE LIMITS. IF MAINTAIN
BELOW PEL/TLV, OTHER OSHA /NIOSH APPROVED RSPRTR MAY BE USED.
Ventilation:EXHAUST VENTILATION SUFFICIENT TO KEEP VAPOR CONCENTRATIONS
BELOW TLVS. REMOVE ALL IGNITION SOURCES.
Other Protective Equipment:THE USE OF LONG SLEEVE AND LONG LEG CLOTHING
IS RECOMMENDED. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:205 TO 338F
Vapor Density:> AIR
Spec Gravity:1.15
Viscosity:*
Evaporation Rate & Reference:0.57 X N-BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:RED LIQUID WITH SOLVENT ODOR
Percent Volatiles by Volume:36.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OR OPEN FLAMES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MUST BE DISPOSED OF IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY
CONTAINERS MUST BE HANDLED WITH CARE (RESIDUE IS FLAMMABLE). DO NOT
INCINERATE CLOSED CO NTAINERS. EPA HZD CODE: D001, F003, F005.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INVISIBLE FLUORESCENT CRAYON - WHITE, 737UV
CAGE:94514
CAGE:94514
============= Composition/Information on Ingredients =============
Ingred Name:ZINC STEARATE
CAS:557-05-1
RTECS #:ZH5200000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:N/K
Ingred Name:PARAFFIN
CAS:8002-74-2
RTECS #:RV0350000
OSHA PEL:2 MG/M3 (FUME)
ACGIH TLV:2 MG/M3 (FUME); 9495
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IN GENERAL LOW TOXICITY NO REPORTED
ADVERSE EFFECTS ATTRIBUTED TO ZINC SULFIDE. CHRONIC: INGESTION MAY
CAUSE NAUSEA, VOMITING & DIARRHEA. PROLONGED SKIN EXPOSURE MAY
CAUSE RASH.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
O*2/ARTF RESP) . EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES.
SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . INGESTION: GIVE
LARGE QUANTITIES OF WATER TO DRINK. INDUCE VOMITING. OBTAIN MEDICAL
ADVICE.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:HIGH TEMPERATURES MAY PRODUCE OXIDES OF
SULFUR A/O HYDROGEN SULFIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:DISPOSE IN ACCORDANCE W/APPROPRIATE GOVERNMENT
REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM MINERAL ACIDS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST AS REQUIRED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:ODORLESS WAX STICK, OFF WHITE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCTION COMPOUNDS AND STRONG OXIDIZERS.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPROPRIATE
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FA1621
CAGE:JO867
CAGE:81831
CAGE:JO867
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR. AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UN CONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TENMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR
PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CER-WOOL GUN MIX HT & RT
CAGE:8C482
CAGE:8C482
============= Composition/Information on Ingredients =============
Ingred Name:INGRED 6:INVESTIGATION AS POS ANIMAL CARCINOGEN. ANIMAL
STUDIES TO DATE ARE INCONCLUSIVE. EXPOS TO DUST FROM (SEE ING 8)
RTECS #:9999999ZZ
Ingred Name:INGRED 7:PROD SHOULD BE MINIMIZED UNTIL FURTHER ANIMAL &
HUMAN STUDIES ARE COMPLETE. PROD IS SUSPECTED TO BE (SEE ING 9)
RTECS #:9999999ZZ
Ingred Name:INGRED 8: AN ANIMAL CARCINOGEN.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:CONDITIONS & PRECS FOR SAFE USE/EXPOSURE.
2.NIOSH/MSHA APPRVD RESP SHOULD BE USED FOR DUST LEVS <(SEE ING 11
RTECS #:9999999ZZ
Ingred Name:INGRED 10:10X PEL. 3. DUST GENERATION SHOULD BE MINIMIZED
BY USE OF DUST CONTROL EQUIP/H*2O SPRAY. 4.WEAR (SEE ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:PROT CLTHG & VACUUM CLEAN PRIOR TO REMOVING CLTHG.
5.WHERE THERE IS POS OF EXPOS OF DUST CONTAINING (SEE ING 13)
RTECS #:9999999ZZ
Ingred Name:INGRED 12:CRYSTALLINE SILICA, THE FOLLOWING WARNING SHOULD
BE POSTED IN A READILY VISIBLE LOCATION:WARNING:(SEE ING 14)
RTECS #:9999999ZZ
Ingred Name:INGRED 13:FREE SILICA WORK AREA, AVOID BRTHG DUST, MAY
CAUSE DELAYED LUNG INJURY (SILICOSIS).
RTECS #:9999999ZZ
Ingred Name:RESP PROT:USED TO CONTROL/REDUCE AIRBORNE CONC. FOR
ACCEPTABLE RESP RECOM FOR GIVEN AIRBORNE CERAMIC FIBER (SEE ING
16)
RTECS #:9999999ZZ
Ingred Name:ING 15: CONC. SEE ORIGINAL MSDS OR CFR 1910.134. PENDING
RSLTS OF LONG-TERM HLTH EFTS STUDIES, ENGINEERING (SEE ING 17)
RTECS #:9999999ZZ
Ingred Name:INGRED 16: CONTROL OF AIRBORNE FIBERS TO LOWEST LEVS
ATTAINABLE IS ADVISED.
RTECS #:9999999ZZ
Ingred Name:CER-WOOL GUN MIX HT & RT (TLV GIVEN FOR MINERAL WOOL FIBER)
ACGIH TLV:10 MG/M3 TDUST (MFR)
Ingred Name:SUPP DATA:CAN CAUSE IRRIT TO EYES ON CONTACT & TO SKIN ON
PRLNGD CONTACT. IF MATL CONTACTS SKIN IT SHOULD BE (SEE ING 3)
RTECS #:9999999ZZ
Ingred Name:INGRED 2:WASHED OFF THORO USING MILD SOAP & H*2O.
ACUTE:IRRIT OF SKIN & UPPER RESP SYS. CHRONIC:CAN OCCUR (SEE ING 4)
RTECS #:9999999ZZ
Ingred Name:INGRED 3:FROM LONG TERM EXCESSIVE INHAL OF CRYSTALLINE
SILICA DUST. CRYSTALLINE SILICA IN LUNGS CAN PRDCE (SEE ING 5)
RTECS #:9999999ZZ
Ingred Name:INGRED 4:PNEUMOCCONIOSIS, COMMONLY CALLED SILICOSIS, WHICH
IS A SLOWLY DEVELOPING DISEASE. SYMP ARE USUALLY (SEE ING 6)
RTECS #:9999999ZZ
Ingred Name:INGRED 5:DELAYED (10 YEARS OR MORE). SMOKING CAN INCR RISK
OF INJ. SUMMARY: CERAMIC FIBER IS UNDER (SEE INGRED 7)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CER-WOOL GUN MIX IS AN INSULATING PROD
CONTAINING CERAMIC FIBER, OF MINERAL FAMILY, FOR REDUCING HEAT
TRANSMISSION THRU FURNACE. PROD AS SOLD CONTAINS <1% CRYSTALLINE
SILICA; HOWEVER, CRYSTALLINE SILI CA (CRISTOBALITE) WILL FORM AFTER
SERVICE AT TEMPERATURES >1000 C. THE "AFTER SERVICE" DUSTS WILL
(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA: IARC GRP 2A.
Effects of Overexposure:HLTH HAZ: TYPICALLY CONTAIN >20% CRISTOBALITE
CAS# 14464-46-1 (CRYSTALLINE SILICA) WHICH CAN PRESENT A HLTH HAZ
IF INHAL OVER LONG PERIODS OF TIME. CURRENT OSHA PERMISSIBLE EXPOS
LIMIT (PEL) IS 5 MG/M 3 DIVIDED BY % FREE SILICA PLUS TWO, AVERAGED
OVER AN 8-HOUR WORK SHIFT. WHEN PROD IS REMOVED AFTER ITS (SEE SUPP
DATA)
Medical Cond Aggravated by Exposure:PRE-EXISTING UPPER RESP & LUNG
DISEASES SUCH AS, BUT NOT LIMITED TO, BRONCHITIS, EMPHYSEMA AND
ASTHMA.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH POTABLE WATER FOR AT LEAST 15 MINUTES .
INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE O*2/ARTF RESP) . SKIN: WASH THOROUGHLY WITH SOAP &
WATER.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE TO SURROUNDING
AREA.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:BECAUSE OF POS PRESENCE OF CRYSTALLINE
SILICA IN FIRED REFRACTORY LININGS, PARTICULAR CARE SHOULD BE
EXERCISED DURING TEAR-OUT TO MIN GEN OF DUST.
Other Precautions:ADHERENCE TO PROPER METHS OF DUST SUPPRESSION &
CONTROL IS IMPERATIVE. FOLLOWING ARE RECOM PRECS TO BE TAKEN DURING
REMOVAL: 1.EMPLOYEES SHOULD BE APPRISED OF HAZ & PROPER (SEE INGRED
10)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:PROVIDE WORKERS W/DUST RESP WHERE DUST LEVS MAY
EXCEED PEL. NIOSH/MSHA APPRVD EQUIP ARE RECOM WHEN AIRBORNE FIBER
EXPOS LIMITS ARE EXCEEDED. NIOSH/MSHA APPRVD BRTHG EQUIP MAY BE
REQD FOR NON-ROUTINE & EMER USE. VENT SHOULD BE (SEE ING 15)
Ventilation:PROVIDE ADEQ GENERAL & LOCAL VENTILATION TO MEET PEL
REQUIREMENTS.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:VACUUM CLEAN PRIOR TO REMOVING CLOTHING.
Supplemental Safety and Health
EFTS OF OVEREXP:USEFUL LIFE (TEAR OUT), DUST GENERATION IS LIKELY. USER
SHOULD BE WARNED OF CURRENT PEL & PRECS SHOULD BE TAKEN TO AVOID
INHAL OF DUST. CER-WOOL (SEE ING 2)
================== Physical/Chemical Properties ==================
HCC:T6
Appearance and Odor:LIGHT GREY, GRANULAR TO FINE MATERIAL, NO
DISTINGUISHABLE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:SOLID WASTE REGULATIONS APPLY. CONSULT LOCAL
STATE AND FEDERAL REGULATORY AGENCIES TO DETERMINE BEST DISPOSAL
ALTERNATIVES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:L-373 CONQUEST=CITRA-SOLV
CAGE:HO510
CAGE:97257
CAGE:HO510
============= Composition/Information on Ingredients =============
Ingred Name:D'LIMONENE
CAS:5989-28-3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAN CAUSE SLIGHT TO MODERATE
IRRITATION TO SKIN, EYES AND RESPRIATORY TRACT. CAN CAUSE NAUSEA,
VOMITING AND DIARRHEA IF SWALLOWED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:OVEREXPOSURE BY INHALATION MAY CAUSE DIZZINESS,
HEADACHE, NAUSEA, AND EVEN LOSS OF CONSCIOUSNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR. IF BREATHING HAS STOPPED, ADMINISTER
ARTF RESP. CALL PHYS. INGEST:DO NOT INDUCE VOMIT. CONTACT PHYS
IMMED. EYE:FLUSH IMMED WITH WATER FOR AT LEAST 15 MIN. SEEK PHYS
IMMED. SKI N:FLUSH WITH PLENTY OF WATER WHILE REMOVING CONTAMINATED
CLOTHING AND SHOES. WASH WITH PLENTY OF SOAP AND WATER FOR 15 MIN.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:144F,62C
Extinguishing Media:WATER FOG, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . DRUMS MAY BUILD PRESSURE AND RUPTURE UNDER
EXTREME HEAT.
Unusual Fire/Explosion Hazard:CONCENTRATED VAPORS CAN BE IGNITED BY
EXTREME HEAT OR ANY IGNITION SOURCE.DO NOT CUT OR WELD DRUM.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN LARGE SPILLS AND PUMP TO RECOVER.
SMALL SPILLS CAN BE MOPPED UP. DO NOT USE CLAY-TYPE ABSORBENT
MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. KEEP
CONTAINER CLOSED WHEN NOT IN USE. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WITH ADEQUATE VENTING. USE NIOSH/
MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:USE ADEQUATE VENTILATION.
Other Protective Equipment:WASH HANDS THOROUGHLY AFTER USE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:1.0
Vapor Density:4.7
Spec Gravity:0.86
Evaporation Rate & Reference:<ETHER(BUTYL ACETATE=1)
Solubility in Water:FORMS EMULSION
Appearance and Odor:CLEAR LIGHT ORANGE LIQUID, PLEASANT CITRUS ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDIC AGENTS INCLUDING CLAYS.
Stability Condition to Avoid:SPARKS, FLAMES, HIGH TEMPERATURES.
Hazardous Decomposition Products:CO, CO2 AND OTHERS POSSIBLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TB-66 ALGAE, FUNGI & SLIME CONTROL
CAGE:0R6X6
CAGE:0R6X6
============= Composition/Information on Ingredients =============
Ingred
Name:POLY[OXYETHYLENE(DIETHYLIMINO)ETHYLENE(DIETHYLIMINO)ETHYLENE
DICHLORIDE]
CAS:31075-24-8
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL) 3.7 G/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATING TO EYES. PRODUCES
REVERSIBLE MINIMAL EFFECTS IN THE FORM OF ERYTHEMA, CHEMOSIS, AND
DISCHARGE. NOT IRRITATING TO SKIN. CHRONIC:NONE LISTED TO
MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:FLUSH WITH WATER FOR
@ LEAST 15 MINUTES. SEE PHYS IF IRRIT OCCURS. SKIN:WASH WITH SOAP
& WATER. SEE PHYS IF IRRIT OCCURS. REMOVE AND WASH CONTAMINATED
CLOTHING.
===================== Fire Fighting Measures =====================
Flash Point:>212F,>100C
Extinguishing Media:WATER FOG, CO*2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:NONE. USE NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:DAM AREA TO PREVENT SPILL FROM ENTERING FISH
BEARING WATERS. PUMP INTO APPROPRIATE CONTAINERS. FOR SMALL SPILLS,
FLUSH LIQUID TO SEWER WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT APPLICABLE. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NOT APPLICABLE.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:GOOD HYGIENIC PRACTICES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.025 (H*2O=1)
Evaporation Rate & Reference:NOT APPLICABLE.
Solubility in Water:COMPLETELY MISCIBLE
Appearance and Odor:CLEAR BROWN LIQUID, SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT IS NOT A HAZARDOUS WASTE. IT CAN BE
DISPOSED OF IN ANY APPROVED LANDFILL. DISPOSAL MUST BE I/A/W
FEDERAL, STATE & LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STYLE 921 BRAIDED PACKING MATERIAL
CAGE:4R345
CAGE:4R345
============= Composition/Information on Ingredients =============
Ingred Name:NATURAL FLAX AND TALLOW WITH TALLOW AND WAX LUBE
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE GIVEN BY MANUFACTURER (SUPPLIER).
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MFR SAID "NOT APPLICIABLE" IN THIS
FIELD.
Explanation of Carcinogenicity:MFR SAID "NOT APPLICIABLE" IN THIS
FIELD.
Effects of Overexposure:MFR SAID "NOT APPLICIABLE" IN THIS FIELD.
Medical Cond Aggravated by Exposure:MFR SAID "NOT APPLICIABLE" IN THIS
FIELD.
======================= First Aid Measures =======================
First Aid:MFR SAID "NOT APPLICIABLE" IN THIS FIELD.
===================== Fire Fighting Measures =====================
Flash Point:NOT RELAVENT
Extinguishing Media:WATER
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:MFR SAID "NOT APPLICIABLE" IN THIS FIELD.
Neutralizing Agent:NONE GIVEN BY MANUFACTURER (SUPPLIER).
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NOT REQUIRED
Other Protective Equipment:NONE REQUIRED
Work Hygienic Practices:NORMAL
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:INSOLUBLE
Appearance and Odor:BROWN WITH GREASY LUBE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS AND ALKALIS
Stability Condition to Avoid:TEMPERATURE IN EXCESS OF 300F
Hazardous Decomposition Products:SMOKE, OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIAL PROCEDURE REQUIRED
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:0625177 (1280441) GREASE 23
CAGE:30874
CAGE:30874
============= Composition/Information on Ingredients =============
Ingred Name:SEVERLY HYDROTREATED HEAVY NAPHTHENIC DISTILLATE
CAS:64742-52-5
RTECS #:PY8035000
Fraction by Wt: 90%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/CUM, OIL MIST
ACGIH TLV:5 MG/CUM, OIL MIST
Ingred Name:BENTONITE (INORGANIC CLAY)
CAS:1302-78-9
RTECS #:CT9450000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (DUST)
ACGIH TLV:5 MG/M3 (DUST)
Ingred Name:FATTY ACID AMINES
CAS:68910-93-0
Fraction by Wt: 4%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM NITRITE (SARA III) (LISTED BY MANUFACTURER AS
"OTHER COMPONENTS)
CAS:7632-00-0
RTECS #:RA1225000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYES:MILD
IRRITATION.SKIN:IRRITATION. RELEASE DURING HIGH PRESSURE USAGE MAY
RESULT IN INJECTION & NECROSIS. INHALATION:VAPORS MAY CAUSE
RESPIRATORY TRACT IRRITATION,HEADACHE,NAUSEA, WEAKNESS,CO
NFUSION.INGESTION:UNKNOWN.CHRONIC-SKIN:POSSIBLE RASH,DERMATITIS,
OIL ACNE; ASTHMA & LUNG DISEASE; ALLERGIC REACTION.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUPECTED CARCINOGEN.
Effects of Overexposure:MILD EYE IRRITATION. SKIN IRRITATION. VAPORS
MAY CAUSE RESPIRATORY TRACT IRRITATION, HEADACHE, NAUSEA, WEAKNESS,
CONFUSION.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN DISORDERS, ASTHMA
AND LUNG DISEASE MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. INHALATION:REMOVE
TO FRESH AIR.PROVIDE ARTIFICIAL RESPIRATION/OXYGEN IF
NEEDED.INGESTION:DO NOT INDUCE VOMITING.CALL PHYSICIAN.EYE:FLUSH
WITH WATER FOR 15 MI NUTES, HOLDING EYELIDS OPEN.SKIN:WIPE EXCESS
OFF.WASH WITH SOAP & WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:464F,240C
Extinguishing Media:USE FOAM, CARBON DIOXIDE, OR DRY CHEMICAL. WATER
MAY CAUSE FROTHING.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. ELIMINATE ALL SOURCES OF
IGNITION. COVER WITH ABSORBENT MATERIAL AND COLLECT. CLEAN AREA
WITH APPROPRIATE CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,VENTILATED
PLACE.KEEP AWAY FROM OPEN FLAMES,HEAT,SPARKS & STRONG OXIDIZERS.
Other Precautions:MINIMIZE SKIN CONTACT. WASH WITH SOAP & WATER BEFORE
EATING, DRINKING, SMOKING OR USING TOILET FACILITIES. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICLES , INCLUDING SHOES,THAT CANNOT BE
CLEANED
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. USE A NIOSH-APPROVED
RESPIRATOR IF NEEDED.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:601F,316C
Vapor Pres:0.01 MM HG
Spec Gravity:0.88 (WATER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:BROWN-AMBER COLORED SMOOTH GREASE - SLIGHT
PETROLEUM ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES AND OTHER
SOURCES OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN AN APPROVED DISPOSAL FACILITY FOR
CHEMICAL LANDFILL, INCINERATION. DISPOSE OF IN COMPLIANCE WITH ALL
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:17-5 METHANOL ABSOLUTE
Kit Part:Y
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS *96-2*
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 99.99%
Other REC Limits:200 PPM
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 5628 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF INHALED, INGESTED/MAY BE
HARMFUL IF ABSORBED THROUGH THE SKIN. EYES/SKIN: IRRITATION.
INHALATION: MAY BE IRRITATING TO MUCOUS MEMBRANES & UPPER
RESPIRATORY TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, GI DISTURBANCES, CONVULSIONS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH EYES/SKIN W/COPIOUS AMOUNTS OF WATER
FOR 15 MINS. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NEEDED. INGESTION: WASH OUT MOUTH W/WATER IF CONSCIOUS. OBTAIN
MEDICAL ATT ENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:52F
Lower Limits:6
Upper Limits:36
Extinguishing Media:CO2, DRY CHEMICAL POWDER/APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE. VAPOR MAY TRAVEL
CONSIDERABLE DISTANCE TO SOURCE OF IGNITION & FLASHBACK.
AUTOIGNITION TEMP: 725F.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. SHUT OFF SOURCES OF IGNITION.
W/DRY-LIME/SAND/SODA ASH. USE NON-SPARKING TOOLS & TRANSPORT
OUTDOORS. VENTILATE AREA & WASH AREA SITE AFTER MATERIAL PICKUP IS
COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. KEEP AWAY FROM
HEAT, SPARKS, OPEN FLAME & SOURCES OF IGNITION. STORE IN A COOL DRY
PLACE.
Other Precautions:DON'T BREATHE VAPOR. AVOID CONTACT W/EYES, SKIN &
CLOTHING. DON'T USE IF SKIN IS CUT/SCRATCHED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER & EYE
BATH.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:148.46F
Melt/Freeze Pt:M.P/F.P Text:-144.4F
Vapor Pres:97.68
Vapor Density:1.1
Spec Gravity:0.791
Appearance and Odor:LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, ACID CHLORIDES, ACID ANHYDRIDES, OXIDIZING AGENTS, REDUCING
AGENTS, ALKALI METALS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, MOISTURE/OTHER
SOURCES OF IGNITION.
Hazardous Decomposition Products:COMBUSTION: CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN
AFTERBURNER & SCRUBBER BUT EXERT CARE IN IGNITING AS THIS MATERIAL
IS HIGHLY FLAMMABLE. DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TT-E-527D BLUE #35044
Preparer's Name:ONEY FLEMING
CAGE:JO954
CAGE:JO954
CAGE:39934
============= Composition/Information on Ingredients =============
Ingred Name:MEDIUM ALIPHATIC SOLVENT NAPHTHA
CAS:64742-88-7
Fraction by Wt: 31.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 68.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:VOC = 2.84 LBS/GL
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: REDNESS, PAIN. SKIN: REDNESS.
INHAL: LABORED BREATHING, DULLNESS, DROWSINESS. INGEST: ABDOMINAL
PAIN, NAUSEA. CHRONIC: EYE: IRRITATION, REDNESS, TEARING, BLURRED
VISION. SKIN: IRRITATION, DEFATTI NG, DERMATITIS. INHAL:
NASAL/RESPIRATORY IRRIT, DIZZINESS, NAUSEA, HEADACHE. INGEST: GI
IRRITATION, NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:RESPIRATORY SYSTEM DISEASES.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINUTES, LIFT
LIDS, GET MED AID. SKIN: REMOVE CONTAM CLOTHES, WASH BEFORE REUSE.
WASH SKIN W/SOAP & WATER. INHAL: REMOVE TO FRESH AIR. GIVE OXYGEN
IF NEEDED.GET MED AID. INGEST: KEEP WARM/QUIET. GET MED AID. DONT
INDUCE VOMIT.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:100F,38C
Autoignition Temp:Autoignition Temp Text:540F
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE SCBA & FULL PROTECTIVE GEAR. USE WATER
SPRAY TO COOL CONTAINERS. (PREVENT PRESSURE
BUILDUP/AUTOIGNITION/EXPLOSION).
Unusual Fire/Explosion Hazard:WATER MAY SPREAD FIRE. VAPORS >AIR, MAY
TRAVEL TO IGNITION SOURCE & FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. COVER W/INERT ABSORBENT. SHOVEL
W/NONSPARKING TOOLS INTO CONTAINER. REMOVE TO SAFE AREA & SEAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLEAN, DRY AREA. KEEP AWAY
FROM IGNITION SOURCES.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED. KEEP AWAY FROM
CHILDREN. GROUND EQUIPMENT TO REDUCE STATIC ELECTRICITY HAZARD. USE
NONSPARKING TOOLS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A RESPIRATOR W/APPROPRIATE CARTRIDGES (NIOSH
APPROVED).
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:EYEWASH STATION, SAFETY SHOWER & IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:752F,400C
Vapor Pres:2.58
Vapor Density:>AIR
Spec Gravity:1.08
pH:NA
Viscosity:65-72 KU
Evaporation Rate & Reference:<ETHER
Solubility in Water:NO
Appearance and Odor:LIQUID, W/SLIGHT ODOR.
Percent Volatiles by Volume:49.52
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:IGNITION SOURCES.
Hazardous Decomposition Products:CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1236 SHRUB GREEN RUSTMASTER ENAMEL
CAGE:01PD6
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 5-10%
Other REC Limits:1900 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *95-2*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10-20%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE *95-2*
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 1-5%
Other REC Limits:100 PPM
OSHA PEL:435 MG/CUM
ACGIH TLV:434 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA *95-2*
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 1-5%
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 30-40%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 1-5%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE, PROPANOIC ACID, 3-ETHOXY-, ETHYL
ESTER
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 5-10%
Ingred Name:TALL OIL FATTY ACIDS, TRIMETHYLOLPROPANE, PENTAERYTHRITOL,
PHTHALIC ANHYDRIDE POLYMER
CAS:67762-04-3
Fraction by Wt: 5-10%
Ingred Name:BENZENE (SUSPECTED HUMAN CARC BY ACGIH, IARC, ANIMAL
CARCINOGEN BY IARC, CARCINOGEN BY NTP - IARC GROUP 1) *95-2*
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 0-0.1%
Other REC Limits:16 MG/CUM
ACGIH TLV:0.3 MG/CUM (A2) IC
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:BUTANE, N-BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 1-5%
Other REC Limits:800 PPM
OSHA PEL:800 PPM
ACGIH TLV:1900 MG/CUM
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 1-5%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10-20%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:VOL ORGANIC CMPD: 758.15 GM/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT & MUCOUS
MEMBRANE IRRITANT/CNS DEPRESSION/RESPIRATORY PROBLEMS/ANESTHETIC
EFFECTS/BRONCHITIS/ABNORMAL BLOOD PRESSURE/LIVER-KIDNEY
DAMAGE/PNEUMOCONIOSIS/RESPIRATORY FAILUR E/ASPHYXIATION/DEATH.
SKIN: IRRITANT/DERMATITIS/ABSORPTION. EYES:
IRRITANT/CONJUNCTIVITIS/CORNEAL INJURY/BLINDNESS(SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS. ACCORDING TO GLIDDEN,
BENZENE IS REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:IRRITATION/LOSS OF
APPETITE/FATIGUE/DROWSINESS/DIZZINESS/LIGHTHEADEDNESS/HEADACHE/UNCO
ORDINATION/NAUSEA/VOMITING/DIARRHEA/CHEST PAIN/BLURRED
VISION/FLU-LIKE SYMPTOMS/COUGHING/SNEEZING/DIFFICULTY BREAT
HING/FEVER/CHILLS/TREMORS/CONVULSIONS/LOSS OF
CONSCIOUSNESS/ASPHYXIATION/DEFATTING/BLISTERING/TEARING/REDNESS/NAR
COSIS.
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY & LUNG
DISORDERS. ASTHMA-LIKE CONDITIONS, KIDNEY/LIVER/NERVOUS SYSTEM
DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN. SKIN: FLUSH W/WATER,
THEN WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH IMMEDIATELY
W/LARGE AMOUN TS OF WATER FOR 15 MINS. OBTAIN MEDICALATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:1F
Extinguishing Media:DRY CHEMICAL/FOAM, WATER FOG, CO2
Fire Fighting Procedures:WATER MAY BE USED TO COOL/PROTECT EXPOSED
CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE/BURST WHEN
EXPOSED TO EXTREME HEAT/FIRE. VAPORS MAY EXPLODE AT AMBIENT
TEMPS/FORM EXPLOSIVE MIXTURES W/AIR AT ELEVATED TEMPS.(SUPP
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE
W/EXPLOSION-PROOF EQUIPMENT/EVACUATE AREA. COLLECT W/ABSORBENT, USE
NON-SPARKING TOOLS. PLACE IN PROPER CONTAINER. SHOUT OFF LEAK
SAFELY. DIKE/CONTAIN/PUMP TO STO RAGE/SALVAGE VESSELS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <80F. KEEP CONTAINERS TIGHTLY
CLOSED/UPRIGHT WHEN NOT IN USE & AWAY FROM IGNITION SOURCES. USE
W/ADEQUATE VENTILATION. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID
CONTACT/SKIN/EYES & BREATHING VAPORS. AVOID CONDITIONS WHICH FORMS
INHALABLE PARTICLES. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE CONTENTS MA Y BE HARMFUL/FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE REQUIRED, USE ONLY NIOSH/MSHA APPROVED
RESPIRATORS IN ACCORDANCE W/OSHA STANDARD 29 CFR 1910.134.
Ventilation:DILUTION/LOCAL EXHAUST TO PREVENT BUILD-UP OF VAPORS. USE
EXPLOSION PROOF NON-SPARKING EQUIPMENT.
Other Protective Equipment:EYE WASH, SAFETY SHOWER, IMPERVIOUS
CLOTHING, APRON, BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. REMOVE/DISPOSE OF CONTAMINATED SHOES. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
HEALTH HAZ CONT'D: INGESTION: LUNG DAMAGE DUE TO ASPIRATION INTO
LUNGS/MOUTH-THROAT-MUCOUS MEMBRANE IRRITANT/CNS
DEPRESSION/ANESTHETIC EFFECT/ABNORMAL BLOOD PRESSURE/LIVER-KIDNEY
DAMAGE/PULMONARY EDEM A/BLINDNESS/PARALYSIS/DEATH. FIRE HAZ CONT'D:
VAPORS >AIR/MAY TRAVEL TO DISTANT IGNITION SOURCE & FLASHBACK.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:11-418F
Appearance and Odor:SHRUB GREEN
Percent Volatiles by Volume:99.71
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS/ACIDS/REDUCING AGENTS/BASES/ALDEHYDES/ALKYL
HALIDES/ISOCYANATES/HALOGENS/AMINES/METALS/SALTS
Stability Condition to Avoid:ELEVATED TEMPS, MOISTURE, HEAT, SPARKS,
OPEN FLAME & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO/CO2/OXIDES OF NITROGEN/OXIDES OF
SULFUR/OXYGEN/HYDROGEN/CHLORIDE/ALDEHYDES/TOXIC GASES/BARIUM
COMPOUNDS/SMOKE/SOOT.
==================== Disposal Considerations ====================
Waste Disposal Methods:AVOID DISCHARGE TO SEWERS/NATURAL WATERS.
DISPOSE OF IAW/LOCAL, STATE & FEDERAL REGULATIONS. EMPTY CONTAINERS
MAY CONTAIN HAZARDOUS RESIDUES. GROUND EQUIPMENT WHEN TRANSFERRING
TO PREVENT ACCUMULATION OF STATIC CHARGE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CREST 1700 A
Kit Part:Y
CAGE:34469
CAGE:34469
============= Composition/Information on Ingredients =============
Ingred Name:ACRYLONITRILE (SUSPECTED HUMAN CARCINOGEN BY IARC,
ACGIH, NTP, OSHA)
CAS:107-13-1
RTECS #:AT5250000
Fraction by Wt: <80%
OSHA PEL:SEE 1910.1045
ACGIH TLV:S, 2 PPM;A2 9394
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:1,3-BUTADIENE
** PROPOSED TWA 2 PPM, STEL 10 PPM, ACTION LEVEL TWA 1 PPM
CAS:106-99-0
RTECS #:EI9275000
Fraction by Wt: <10%
Other REC Limits:10 PPM
OSHA PEL:2200 MG/CUM **
ACGIH TLV:22 MG/CUM (A2)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:HYDROGEN CYANIDE
CAS:74-90-8
RTECS #:MW6825000
Fraction by Wt: <10%
Other REC Limits:10 PPM
OSHA PEL:S, 10 PPM STEL
ACGIH TLV:S, C 10 PPM; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:LIQUID CONTACT W/EYES OR SKIN MAY
CAUSE IRRITATION. PROCESSING VAPORS MAY CAUSE LUNG IRRITATION IF
INHALAED. SKIN: DERMATITIS.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:EYES/SKIN/LUNG: IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. INGESTION:
DON'T INDUCE VOMITING. INHALATION: REMOVE TO FRESH AIR. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>110C
Extinguishing Media:WATER, ABC DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SILL, RECOVER AS MUSH AS POSSIBLE FOR
REUSE. ABSORB REMAINING SPILL W/INERT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING VAPORS. KEEP
CONTAINERS CLOSED WHEN NOT IN USE. HANDLE & USE IN WELL-VENTILATED
CONDITIONS.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHAUST
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:.95
Solubility in Water:NEGLIGIBLE
Appearance and Odor:VISCOUS, BLACK LIQUID, SLIGHT CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN, AMMONIA.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NUTS N' BOLTS 223
Preparer's Name:JOSEF ARNON
CAGE:JO919
CAGE:61603
CAGE:JO919
============= Composition/Information on Ingredients =============
Ingred Name:POLYGLYCOL DIMETHACRYLATES
Fraction by Wt: 60-65%
Ingred Name:BIS-PHENOL A FUMARATE RESIN
Fraction by Wt: 30-35%
Ingred Name:1-METHYL-1-PHENYLETHYL HYDROPEROXIDE (CUMENE HYDROPEROXIDE)
(SARA III)
CAS:80-15-9
RTECS #:MX2450000
Fraction by Wt: 3%
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:N,N-DIALKYLTOUIDINES
Fraction by Wt: <1%
Ingred Name:SACCHARIN (SARA III)
CAS:81-07-2
RTECS #:DE4200000
Fraction by Wt: <1%
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE
Explanation of Carcinogenicity:NOT LISTED IN ANY OF THE ABOVE
Effects of Overexposure:MAY CAUSE DERMATITIS ON PROLONGED CONTACT IN
SENSITIVE INDIVIDUALS
Medical Cond Aggravated by Exposure:SAME AS ABOVE
======================= First Aid Measures =======================
First Aid:INGESTION: DO NOT INDUCE VOMITING. KEEP INDIVIDUAL CALM.
OBTAIN MEDICAL ATTENTION. INHALATION: DOES NOT APPLY. SKIN: FLUSH
WITH WATER AND EYES: FLUSH WITH WATER
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:> 200 F 93.33 C
Lower Limits:DNA
Upper Limits:DNA
Extinguishing Media:CO2, FOAM, DRY CHEMICAL
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP IN AN INERT ABSORBENT. STORE IN
PARTLY-FILLED, CLOSED CONTAINER UNTIL DISPOSAL
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 110 F TO PRESERVE
SHELF-LIFE. AVOID PROLONGED SKIN CONTACT
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NECESSARY
Ventilation:NOT NORMALLY NECESSARY, MECHANICAL REQUIRED
Other Protective Equipment:NONE
Work Hygienic Practices:AS REQUIRED
Supplemental Safety and Health
AS DEFINED BY NTP, ARC, OSHA, NIOSH, AND ACGIH, THERE ARE NO HAZARDOUS
INGREDIENTS IN THIS FORMULATION.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:> 300 F
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:<5MM@ 80 F
Spec Gravity:1.068 @ 80 F
pH:DNA
Solubility in Water:SLIGHT
Appearance and Odor:RED LIQUID, ODOR-MILD
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:IRRITATING ORGANIC VAPORS
==================== Disposal Considerations ====================
Waste Disposal Methods:BURY OR INCINERATE IN ACCORDANCE WITH EPA AND
LOCAL REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WHITE SHELLAC
CAGE:TREND
CAGE:TREND
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 77.5%
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SHELLAC; (REGULAR BLEACHED WHITE SHELLAC)
Fraction by Wt: 22.5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST: CAUSES INEBRIATION, HEADACHE,
NAUSEA, VOMITING, LEADING TO SEVER ILLNESS, BLINDNESS, DEATH. EYES:
LIQUID CAUSES IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION OR
OXYGEN. EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH SOAP & WATER. INGEST: INDUCE VOMITING AT ONCE. THEN 2
TABLESPOONS BAKIN G SODA IN WATER. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:54.0F,12.2C
Lower Limits:6%
Upper Limits:36.5%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . ADDITION OF WATER TO BURNING FUEL WILL
REDUCE INTENSITY OF FLAME.
Unusual Fire/Explosion Hazard:NONE: HANDLE AS FLAMMABLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL QUANTITIES MAY BE DILUTED WITH WATER &
FLUSHED DOWN DRAIN. LARGE QUANTITIES COVER WITH ABSORBENT MATERIAL.
PLACE IN DISPOSAL CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID OPEN FLAME OR SPARKS.
Other Precautions:FLUSH WITH WATER TO WELL VENTILATED AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC CANISTER PACH OR AIR
PACK.
Ventilation:USE ADEQUATE VENTILATION. LOCAL EXHAUST IS DESIRABLE.
MECHANICAL: SPARK PROOF.
Other Protective Equipment:OVERALLS OR APRON.
Work Hygienic Practices:AVOID PROLONGED BREATHING OF VAPORS, OPEN
FLAME, SPARKS.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F5
Boiling Pt:B.P. Text:148F,65C
Vapor Pres:96
Vapor Density:1.11
Spec Gravity:8
Solubility in Water:SLIGHTLY
Appearance and Odor:MILKY WHITE, DARK ORANGE. MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:AVOID OPEN FLAME, SPARKS EXCESSIVE HEAT.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN SUITABLE FURNACE. BURY IN APPROVED
LAND FILL. DISPOSAL MUST BE IN ACCORDANCE WITH STATE, FEDERAL AND
LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:03 305 WEATHERSHIELD EXT ACRYLIC SEMI-GLOSS HOUSE PAINT
CAGE:55652
CAGE:55652
============= Composition/Information on Ingredients =============
Ingred Name:PROPANOIC ACID, 2-METHYL, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL, TEXANOL(ESTER ALCOHOL)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 1.8-2.6%
Ingred Name:3-IODO-2-PROPYNYL BUTYL CARBAMATE
CAS:55406-53-6
RTECS #:EZ0950000
Fraction by Wt: 0-0.2%
Ingred Name:ACRYLIC RESIN
Fraction by Wt: 22.2-27%
Ingred Name:CHLOROTHALONIL; TETRACHLOROISOPHTHALONITRILE; DACONIL;
BRAVO (SUSP ANIMAL CARC BY IARC GRP 3) *98-3*
CAS:1897-45-6
RTECS #:NT2600000
Fraction by Wt: 0-0.9%
Ingred Name:ETHYLENE GLYCOL *98-3*
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 1.6-4%
Other REC Limits:10 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CLAY (KAOLIN), ALUMINUM SILICATE *98-3*
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 1.8-7%
ACGIH TLV:10 MG/CUM TOTAL DUST
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*98-3*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-25%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 43-61.6%
Ingred Name:VOLATILE ORGANIC CONTENT: 1.42 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL/RESPIRATORY
IRRITANT. OVEREXPOSURE CAUSES NEUROLOGICAL DAMAGE. PULMONARY
EDEMA/BRONCHIAL PNEUMONIA. SKIN: IRRITATION. EYES:
IRRITATION/SEVERE CONJUNCTIVITIS. INGESTION: GI IRRITATION ,
ASPIRATION INTO LUNGS MAY CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE
FATAL. (SEE SUPPLEMENTAL DATA)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, MENTAL SLUGGISHNESS, REDNESS, TEARING, FLURRED
VISION, VOMITING, DIARRHEA, LIGHTHEADEDNESS
======================= First Aid Measures =======================
First Aid:INHALATION: SEEK AIR FREE OF VAPORS. IF BREATHING STOPS,
BEGIN ARTIFICIAL RESPIRATION. SKIN: THOROUGHLY WASH W/SOAP & LARGE
QUANTITIES OF WATER FOR 15 MINS. EYES: FLUSH W/LARGE QUANTITIES OF
WATER FOR 15 MINS. INGESTION: DRINK 1-2 GLASSES OF WATER TO
DILUTE. DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2/DRY CHEMICAL
Fire Fighting Procedures:USE SCBA. WATER MAY BE UNSUITABLE AS AN
EXTINGUISHING MEDIA, BUT HELPFUL TO KEEP ADJACENT CONTAINERS COOL.
AVOID SPREADING BURNING LIQUID W/WATER USED TO COOL.
Unusual Fire/Explosion Hazard:VAPORS ARE >AIR, MAY TRAVEL ALONG THE
GROUND/BE MOVED BY VENTILATION TO DISTANCES FROM HANDLING POINT.
NEVER USE A WELDING/CUTTING TORCH ON/NEAR CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. RECOVER FREE
PRODUCT. ADD SAND/EARTH/OTHER SUITABLE ABSORBENT TO AREA. MINIMIZE
SKIN CONTACT. VENTILATE CONFINED SPACES. KEEP PRODUCT OUT OF SEWERS
& WATERCOURSES BY DI KING/IMPOUNDING.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. FOR EXTERIOR USE
IN WELL VENTILATED AREAS. KEEP PRODUCT OUT OF THE REACH OF
CHILDREN.
Other Precautions:USE OF THIS PRODUCT INSIDE/TO TREAT ANY MATERIAL USED
INSIDE ANY BUIDLING/STRUCTURE MAY BE HAZARDOUS TO YOUR HEALTH & TO
THOSE OCCUPYING THE BUILDING. DON'T EAT, DRINK/SMOKE WHILE USING
THIS PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR DEPENDING ON
VAPOR CONCENTRATIONS ABOVE THE TIME WEIGHTED TLV.
Ventilation:SUFFICIENT MECHANICAL GENERAL/LOCAL EXHAUST TO MAINTAIN
EXPOSURE BELOW TLV.
Other Protective Equipment:FACESHIELDS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. THOROUGHLY WASH HANDS BEFORE EATING/SMOKING.
Supplemental Safety and Health
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING CONTENTS MAY BE HARMFUL/FATAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1.12
pH:7.5
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:COMPLETE
Appearance and Odor:VISCOUS LIQUID W/MILD ODOR; DEEP BASE
Percent Volatiles by Volume:69.1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS/BASES, SELECTED AMINES
Stability Condition to Avoid:IGNITION SOURCES: FLARES, FLAMES, PILOT
LIGHTS, ELECTRICAL SPARKS, FREEZING
Hazardous Decomposition Products:BY THERMAL DECOMPOSITION: CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MXT149
CAGE:08040
CAGE:08040
============= Composition/Information on Ingredients =============
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
===================== Hazards Identification =====================
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
======================= First Aid Measures =======================
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
================== Accidental Release Measures ==================
======================Handling and Storage ======================
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-MIL HANDBOOK 600-1 SEP 76.SAFETY & HEALTH DATA DEVELOPED
BY DGSC-STF.
================== Physical/Chemical Properties ==================
HCC:A3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MAGNESIUM CHLORIDE HEXAHYDRATE, NC9523446, S800631
Resp. Party Other MSDS Num.:13365, CAT NO: M33500, INDEX: A00627683
CAGE:DO274
Contract Num:00MC7474001
CAGE:DO274
============= Composition/Information on Ingredients =============
Ingred Name:MAGNESIUM CHLORIDE HEXAHYDRATE. (EINECS #: UNLISTED)
CAS:7791-18-6
RTECS #:OM2975000
= Wt:100.
Other REC Limits:NIOSH;NONE LISTED
OSHA PEL:NONE LISTED
OSHA STEL:NONE LISTED
ACGIH TLV:NONE LISTED
ACGIH STEL:NONE LISTED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: 7800 MG/KG; ORAL, MOUSE.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EMERGENCY OVERVIEW: WARNING! MAY CAUSE
KIDNEY DAMAGE. CAUSES EYE AND SKIN IRRITATION. CAUSES DIGESTIVE AND
RESPIRATORY TRACT IRRITATION. INHALATION OF FUMES MAY CAUSE
METAL-FUME FEVER. TARGET ORGANS: KIDNEYS.POTENTIAL HEALTH
EFFECTS: EYE: MAY CAUSE MILD EYE IRRITATION. SKIN: MAY CAUSE SKIN
IRRITATION. INGESTION: CAUSES GASTROINTESTINAL IRRITATION WITH
NAUSEA, VOMITING AND DIARRHEA. MAY CAUSE KID NEY DAMAGE.
INHALATION: MAY CAUSE RESPIRATORY TRACT IRRITATION. INHALATION OF
FUMES MAY CAUSE METAL FUME FEVER, WHICH IS CHARACTERIZED BY
FLU-LIKE SYMPTOMS WITH METALLIC TASTE, FEVER, CHILLS, COUGH, (
SIGNS AND SYMPTOMS OF OVEREXPOSURE)
Explanation of Carcinogenicity:NOT LISTED BY ACGIH, IARC, NIOSH, NTP,
OR OSHA.
Effects of Overexposure:HEALTH HAZARDS ACUTE AND CHRONIC (CONT):
WEAKNESS, CHEST PAIN, MUSCLE PAIN AND INCREASED WHITE BLOOD CELL
COUNT. CHRONIC: MAY CAUSE KIDNEY DAMAGE.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES, OCCASIONALLY LIFTING THE UPPER AND LOWERE EYELIDS. GET
MEDICAL AID. SKIN: IMMEDIATELY FLUSH SKIN WITH PLENTY OF SOAP AND
WATER FOR AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING
AND SHOES. GET MEDICAL AID IF IRRITATION DEVELOPS OR PERSISTS. WASH
CLOTHING BEFORE REUSE. INGESTION: DO NOT INDUCE VOMITING. IF VICTIM
IS CON SCIOUS AND ALERT, GIVE 2-4 CUPFULS OF MILK OR WATER. GET
MEDICAL AID. INHALATION: GET MEDICAL AID IMMEDIATELY. REMOVE FROM
EXPOSURE TO FRESH AIR IMMEDIATELY. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRAT ION. IF (SUPPLEMENTAL SAFETY AND HEALTH)
===================== Fire Fighting Measures =====================
Flash Point:NOT AVAILABLE.
Autoignition Temp:Autoignition Temp Text:N/AV.
Lower Limits:N/AVAILABLE
Upper Limits:N/AVAILABLE
Extinguishing Media:USE EXTINGUISHING MEDIA MOST APPROPRIATE FOR THE
SURROUNDING FIRE.
Fire Fighting Procedures:MATERIAL WILL NOT BURN. DURING A FIRE,
IRRITATING AND HIGHLY TOXIC GASES MAY BE GENERATED BY THERMAL
DECOMPOSITION OR COMBUSTION. USE WATER WITH CAUTION AND IN FLOODING
AMOUNTS. USE NIOSH APPROVED S CBA AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTACT WITH MOISTURE OR WATER MAY
GENERATE SUFFICIENT HEAT TO IGNITE NEARBY COMBUSTIBLE MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:GENERAL INFORMATION: USE PROPER PERSONAL
PROTECTIVE EQUIPMENT AS INDICATED IN (CONTROL MEASURES) SECTION.
SPILLS / LEAKS: CLEAN UP SPILLS IMMEDIATELY, OBSERVING
PRECAUTIONS IN THE PROTECTIVE EQUI PMENT SECTION. SWEEP UP OR
ABSORB MATERIAL, THEN PLACE INTO A SUITABLE CLEAN, DRY, CLOSED
CONTAINER FOR DISPOSAL. AVOID GENERATING DUSTY CONDITIONS. PROVIDE
VENTILATION.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLING: WASH HANDS BEFORE EATING.
USE WITH ADEQUATE VENTILATION. MINIMIZE DUST GENERATION AND
ACCUMULATION. AVOID CONTACT WITH EYES, SKIN, AND CLOTHING.
STORAGE: STORE IN A COOL, DRY, WELL-VENT ILATED AREA AWAY FROM
INCOMPATIBLE SUBSTANCES. KEEP AWAY FROM WATER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1910.134 OR EUROPEAN STANDARD EN 149. ALWAYS USE A NIOSH OR
EUROPEAN STANDARD EN 149 APPROVED RESPIRATOR WHEN NECESSARY.
EXPOSURE LIMITS: (SE E INGREDIENTS SECTION - ). OSHA VACATED PELS:
MAGNESIUM CHLORIDE HEXAHYDRATE: NO OSHA VACATED PELS ARE LISTED FOR
THIS CHEMICAL.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL
AIRBORNE LEVELS.
EXPOSURE.
Other Protective Equipment:FACILITIES STORING OR UTILIZING THIS
MATERIAL SHOULD BE EQUIPPED WITH AN EYEWASH FACILITY AND A SAFETY
SHOWER. WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN
EXPOSURE.
Work Hygienic Practices:WASH CLOTHING BEFORE REUSE. WASH HANDS BEFORE
EATING.
Supplemental Safety and Health
SYNONYMS: DUS-TOP; MANGOGENE. FIRST AID (CONT): BREATHING IS
DIFFICULT, GIVE OXYGEN. DO NOT USE MOUTH-TO-MOUTH RESPIRATION.
NOTES TO PHYSICIAN: TREAT SYMPTOMATICALLY AND SUPPORTIVELY.
ANTIDOTE: THE USE OF CALCIUM GLUCONATE TO PRECIPITATE THE OXALATE
SHOULD BE DETERMINED BY ONLY QUALIFIED MEDICAL PERSONNEL.
================== Physical/Chemical Properties ==================
Boiling Pt:=1412.C, 2573.6F
Melt/Freeze Pt:=118.C, 244.4F
Decomp Temp:=100.C, 212.F
Vapor Pres:NOT AVAILABLE.
Vapor Density:N/AVAIL.
Spec Gravity:1.569
pH:7.0 (SOLUTION).
Viscosity:NOT AVAILABLE.
Evaporation Rate & Reference:NOT AVAILABLE.
Solubility in Water:SOLUBLE IN WATER/ALCOHOL.
Appearance and Odor:WHITE TO GRAY WHITE SOLID. ODOR: NONE REPORTED.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EXPLOSIVE WHEN COMBINED WITH 2-FURAN PERCARBOXYLIC ACID. MAGNESIUM
CHLORIDE DISSOLVES IN AQUEOUS SOLUTIONS GIVING OFF CONSIDERABLE
AMOUNTS OF HEAT. INCOMPATIBLE WITH STRONG OXIDIZERS.
Stability Condition to Avoid:CONTACT WITH WATER, HEATING TO
DECOMPOSITION. STABLE UNDER NORMAL TEMPERATURES AND PRESSURES.
Hazardous Decomposition Products:HYDROGEN CHLORIDE, CHLORINE.
=================== Toxicological Information===================
Toxicological Information:LD50/LC50: CAS # 7791-18-6: ORAL, MOUSE: LD50
= 7600 MG/KG; ORAL, RAT: LD50 = 8100 MG/KG. EPIDEMIOLOGY: NO
INFORMATION FOUND. TERATOGENICITY: NO INFORMATION FOUND.
REPRODUCTIVE EFFECTS: NO INFORMATION FOUND. NEUROTOXICITY: NO
INFORMATION FOUND. MUTAGENICITY: NO INFORMATION FOUND. OTHER
STUDIES: SEE ACTUAL ENTRY IN RTECS FOR COMPLETE INFORMATION.
===================== Ecological Information =====================
Ecological:ECOTOXICITY: NOT AVAILABLE.ENVIRONMENTAL FATE: NOT
AVAILABLE.PHYSICAL/CHEMICAL: NOT AVAILABLE. OTHER: NOT
AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS. RCRA P-SERIES: NONE LISTED.RCRA
U-SERIES: NONE LISTED.
=================== MSDS Transport Information ===================
Transport Information:US DOT: NO INFORMATION AVAILABLE. CANADIAN TDG:
NO INFORMATION AVAILABLE.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302 (RQ): NONE OF THE CHEMICALS IN
THIS MATERIAL HAVE AN RQ. SECTION 302 (TPQ): NONE OF THE CHEMICALS
IN THIS PRODUCT HAVE A TPQ. SECTION 313: NO CHEMICALS ARE
REPORTABLE UNDER SECTION 313.
Federal Regulatory Information:TSCA: CAS# 7791-18-6 IS NOT LISTED ON
THE TSCA INVENTORY. IT IS FOR RESEARCH AND DEVELOPMENT USE ONLY.
HEALTH AND SAFETY REPORTING UNIT: NONE OF THE CHEMICALS ARE ON THE
HEALTH AND SAFETY REPORTING L IST.CHEMICAL TEST RULES: NONE OF
THE CHEMICALS IN THIS PRODUCT ARE UNDER A CHEMICAL TEST RULE.
SECTION 12B: NONE OF THE CHEMICALS ARE LISTED UNDER TSCA SECTION
12B. TSCA SIGNIFICANT NEW USE RULE: NONE OF THE CHEMICALS IN THIS
MATERIAL HAVE A SNUR UNDER TSCA. CLEAN AIR ACT: THIS MATERIAL DOES
NO T CONTAIN ANY HAZARDOUS POLLUTANTS, CLASS 1 OZONE DEPLETORS, OR
CLASS 2 OZONE DEPLETORS. CLEAN WATER ACT: NONE OF THE CHEMICALS
(STATE REG)
State Regulatory Information:MAGNESIUM CHLORIDE HEXAHYDRATE IS NOT
PRESENT ON STATE LISTS FORM CA, PA, MN, MA, FL, OR NJ. CALIFORNIA
NO SIGNIFICANT RISK LEVEL: NONE OF THE CHEMICALS IN THIS PRODUCT
ARE LISTED. FED R EGS (CONT): THIS PRODUCT ARE LISTED
AS HAZARDOUS SUBSTANCES, PRIORITY POLLUTANTS, OR TOXIC POLLUTANTS
UNDER THE CWA. OSHA: NONE OF THE CHEMICALS IN THIS PRODUCT ARE
CONSIDERED HIGHLY HAZARDOUS BY OSHA . EUROPEAN/INTERNATIONAL
REGULATIONS: EUROPEAN LABELING IN ACCORDANCE WITH EC DIRECTIVES:
HAZARD SYM BOLS: NOT AVAILABLE. RISK PHRASES: N/P. SAFETY PHRASES:
N/P. WGK (WATER DANGER/PROTECTION): CAS # 7791-18-6: 0. CANADA:
NONE OF (OTHER INFO)
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RISOGRAPH RA INK GREEN (S-577)
CAGE:0LJK9
CAGE:0LJK9
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:RESIN
Ingred Name:EMULSIFIERS
Ingred Name:PIGMENT
Ingred Name:ADDITIVES
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED (C10-C15 SATURATED
HYDROCARBONS 97%, C10 AROMATICS 3%) *95-2*
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: <5%
Other REC Limits:200 PPM EXXON
Ingred Name:HYDROTREATED LIGHT PARAFFINIC DISTILLATE, MINERAL OIL,
PETROLEUM DISTILLATES
CAS:64742-55-8
RTECS #:PY8036500
Fraction by Wt: 10-20%
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, ACID-TREATED HEAVY
NAPHTHENIC
CAS:64742-18-3
RTECS #:PY8032000
Fraction by Wt: 10-20%
Ingred Name:GLYCERINE, 1,2,3,-TRIHYDROXYPROPANE, GLYCEROL, ANHYDROUS
GLYCERINE, GLYCERIN
CAS:56-81-5
RTECS #:MA8050000
Fraction by Wt: <10%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (VAPOR)
Ingred Name:COLUMBIA CARBON, CARBON BLACK, LAMPBLACK, BLACK PEARLS
(IARC CARC GROUP 3) - *95-2*
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <5%
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/CUM
ACGIH TLV:3.5 MG/CUM
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RATS): > 2000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HIGH VAPOR CONCENTRATIONS ARE A LITTLE
IRRITATING TO EYES & THE RESPIRATORY TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. INHALATION: REMOVE
TO FRESH AIR IMMEDIATELY. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Extinguishing Media:CO2, DRY CHEMICAL, FOAM/WATER SPRAY
Unusual Fire/Explosion Hazard:NO UNUSUAL FIRE & EXPLOSION HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:MATERIAL SHOULD BE WIPED UP W/CLOTH/PAPER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT TEMPERATURE BETWEEN 11-86F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:REQUIRED IN CASE OF HANDLING A LARGE AMOUNT.
Ventilation:MECHANICAL (GENERAL)
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F
Melt/Freeze Pt:M.P/F.P Text:<32F
Spec Gravity:1-1.02
Solubility in Water:NEGLIGIBLE
Appearance and Odor:EXTREMELY VISCOUS COLORED LIQUID W/SLIGHT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION IS PREFERABLE. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS. NA 1923
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:HYDROCIDE HLM 5000 (ALL GRADES), 30-487
Preparer's Name:MARK S. HORTON
CAGE:IO881
CAGE:IO881
CAGE:63472
============= Composition/Information on Ingredients =============
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (HYDROUS
MAGNESIUM SILICATE)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 15-30%
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:BENZENE, 2,4-DIISOCYANATO-1-METHYL-; (2,4-TOLUENE
DIISOCYANATE) (SARA III). VP:0.02 @ @ 20C. LD50:(ORAL,RAT)5800
MG/KG.
CAS:584-84-9
RTECS #:CZ6300000
Fraction by Wt: <0.5%
OSHA PEL:0.02 PPM, C
ACGIH TLV:0.005 PPM;0.02 STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ASPHALT; (PETROLEUM)
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: 5-15%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (FUME)
Ingred Name:LIGROINE; (VM&P NAPHTHA) (ALIPHATIC PETROLEUM DISTILLATE).
VP:27 @ 20C.
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 5-15%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC
HYDROCARBON BLEND). VP:3 @ 20C. LD50:(ORAL,RAT) 4700 MG/KG.
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 5-15%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:BENZENE, 1,2,4-TRIMETHYL-; (1,2,4-TRIMETHYLBENZENE) (SARA
III)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 1-5%
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:MINERAL OIL, PETRO DISTIL, SOLV REFINED (SEV), HEAVY
NAPHTHENIC; (PETROLEUM PROCESS OIL). VP:0.009 @ 20C.
CAS:64741-96-4
RTECS #:PY8040001
Fraction by Wt: 1-5%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPONENT: 1.96 LBS/GAL MAX.
RTECS #:9999999VO
Ingred Name:EFTS OF OVEREXP:DURING NORMAL USE OF THIS PROD. HOWEVER,
THERE ARE REPORTS THAT RELATIVELY MILD PNEUMOCONIOSIS (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:CAN DEVELOP OVER 10-40 YRS OF OCCUP EXPOS TO MIXED
DUSTS CNTNG TALC. PULM DISEASE WHICH DEVELOPS AFTER (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:SUCH PRLNG EXPOS MAY EXIST WITH OR W/OUT IMPAIRMENT
IN LUNG FUNCTION. PRLNG INHAL OF FREE DUST MAY (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:PROVOKE FIBROTIC RESPONSE SIMPLY BECAUSE OF INSOL
NATURE OF MINERAL TALC. STUDIES SUGGEST THAT SOLV (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:CHRONIC OVEREXP &/OR SYSTEMIC TOX EFTS ARE TARGETED
AT KIDNEYS & CNS. RPTD & PRLNG SKIN CONT MAY CAUSE (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:PRONOUNCED PHOTOSENSITIZATION EFFECT.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:BELOW HIPS TO AVOID ASPIRATION OF VOMITUS
INTO LUNGS. OBTAIN IMMEDIATE MEDICAL ATTENTION.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:APPROPRIATE WASTE AREA. WASH SPILL AREA W/SOAP &
WATER. PREVENT WASHINGS FROM ENTERING WATERWAYS.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:SUPPLIED-AIR RESPIRATOR I/A/W APPLICABLE HEALTH &
SAFETY REGULATIONS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:MOD IRRIT. MAY CAUSE
REVERSIBLE CORNEAL INJURY. SKIN:MOD IRRIT. MAY CAUSE DERM &
ALLERGIC RESPONSE. RPTD/PRLNG OVEREXP MAY CAUSE SENSIT. INHAL:RESP
IRRIT & INTOXICANT. OVEREXP SHOWN BY HDCH , DIZZ & CONFUSN TO COMA.
MATL ASPIR INTO LUNGS MAY CAUSE CHEM PNEUM. INGEST:MAY CAUSE IRRIT
OF MOUTH, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:TOLUENE DIISOCYANATE(2,4):IARC SUPP 7,
PG 56, 1987:GROUP 2B; ANTICIPATED CARCINOGEN, NTP 7TH ANN REPORT,
1994. LIVER.
Effects of Overexposure:HLTH HAZ:THROAT & STOM. SYMPS INCL NAUS, ABDOM
PAIN & POSS COLLAPSE. CHRONIC:RECENT STUDIES INDICATE THAT OVEREXP
TO TDI MAY BE ASSOC W/CHRONIC LUNG IMPAIRMENT. PULM EDEMA MAY OCCUR
AFTER SERIOUS VAP EXPOS. THIS PROD CONTAINS ENCAPSULATED HYDROUS
MAGNESIUM SILICATE (TALC). NO EXPOS TO RESPIRABLE TALC IS ANTIC
(ING 9)
Medical Cond Aggravated by Exposure:PREEXISTING PULMONARY &
DERMATOLOGICAL DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO HAZARDOUS
COMPONENTS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS. OBTAIN IMMED
MED ATTN. SKIN:REMOVE CONTAM CLTHG. WASH AFFECTED AREA(S) THORO
W/SOAP & WATER. CONSULT MD. INHAL:REMOVE TO FRESH AIR. IF BRTHG IS
DFCLT, GIVE OXYGEN. ADMIN ARTF RESP IF NOT BRTHG. OBTAIN MED ATTN.
INGEST:DO NOT INDUCE VOMIT. GIVE WATER/MILK IF VICTIM IS CONSCIOUS
& NOT DROWSY. SHOULD VOMIT OCCUR, BE SURE TO KEEP VICTIM'S HEAD
(ING 15)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:122F,50C
Lower Limits:0.9% & INGS
Upper Limits:7%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
USE WATER TO COOL CLSD CNTNRS. WATER STREAM DIRECTED INTO FIRE MAY
CAUSE FROTHING W/SUBSEQUENT (SUPP DATA)
Unusual Fire/Explosion Hazard:IRRIT &/OR TOX GASES/FUMES MAY BE
GENERATED BY THERMAL DECOMP/COMBUST. CLSD CNTNRS MAY
RUPTURE/EXPLODE (DUE TO PRESS BUILD-UP) WHEN EXPOS TO EXTREME
(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. WEAR APPROP PROT EQUIP DURING
CLEANUP. ELIM SOURCES OF IGNIT. SHUT OFF SOURCE OF LEAK IF SAFE TO
DO SO. DIKE/CONTAIN SPILL. ABSORB W/INERT MATL SUCH AS VERMICULITE.
SWEEP/SHOVEL INTO C NTNRS W/LIDS. COVER LOOSELY & REMOVE TO(ING 16)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:FOR PROFESSIONAL USE ONLY. DO NOT TAKE
INTERNALLY. AVOID CONT W/EYES, SKIN & CLTHG. AVOID BRTHG
VAPS/DUST/MIST. USE ONLY W/ADEQ VENT.
Other Precautions:TIGHTLY RESEAL ALL PARTIALLY USED CNTNRS. STORE AWAY
FROM SOURCES OF VENT. KEEP OUT OF REACH OF CHILDREN. DO NOT REUSE
EMPTY CNTNR W/OUT COMMERCIAL CLEAN/RECNDTN. STORE EMPTY CNTNR AWAY
FROM HEAT & FL AME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED, IF USE IS PERFORMED IN
POORLY VENTILATED CONFINED SPACE/AREA W/LTD VENT, USE NIOSH/MSHA
APPRVD ORGANIC VAPOR CARTRIDGE RESP I/A/W 29 CFR 1910.134. IF VAP
LEVELS ARE 10 X TLV/GREATE R, USE NIOSH/MSHA APPRVD (ING 17)
Ventilation:LOCAL EXHAUST AS NEEDED TO CONTROL VAPOR/DUST LEVELS TO
BELOW RECOMMENDED LIMITS.
Other Protective Equipment:ACCESSIBLE EYE WASH & SAFETY SHOWER. CLEAN
PROTECTIVE CLOTHING, RUBBER APRON.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH:SLIGHTLY ALKALINE. FIRE FIGHT PROC:SPREAD OF FIRE. EXPLO HAZ:HEAT.
VAP IS HVR/AIR & MAY TRAVEL ALONG GROUND TO BE REIGNITED AT
LOCATIONS DIST FROM SOURCE; FLASHBACK OF FLAME MAY OCCUR. EMPTY
CNTNRS MAY CONTAIN EXPLO VAPS/DANGEROUS RESIDUES. DO NOT CUT,
PUNCTURE/WELD ON/NEAR CNTNR. MATLS TO AVOID:UNCONTROLLED CNDTNS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.13
pH:SUPDAT
Evaporation Rate & Reference:SLOWER (REL TO N-BUAC)
Solubility in Water:NEGLIGIBLE (<0.1%)
Appearance and Odor:SMOOTH BLACK VISCOUS MATERIAL W/ASPHALT ODOR.
Percent Volatiles by Volume:20-30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, STRONG BASES/OXIDANTS, STRONG LEWIS/MINERAL ACIDS,
AMINE HARDENERS, IN LG MASSES/UNDER (SUPP DATA)
Stability Condition to Avoid:SOURCES OF IGNITION.
Hazardous Decomposition Products:ACRID SMOKE, OXIDES OF CARBON, TOXIC
NITROGENOUS OXIDES, TRACES OF HYDROGEN CYANIDE IN OXYGEN-DEFICIENT
ENVIRONMENT.
==================== Disposal Considerations ====================
Waste Disposal Methods:REVIEW ALL LOCAL, STATE & FEDERAL REGULATIONS
CONCERNING HEALTH & POLLUTION FOR APPROPRIATE DISPOSAL PROCEDURES.
EPA RCRA WASTE #:D001.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AQUAPOL 302-0034
Resp. Party Other MSDS Num.:ERC-459
CAGE:JO574
CAGE:JO574
CAGE:050Q3
CAGE:54686
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
= Wt:100.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION:MAY CAUSE NAUSEA AND
DIARRHEA. INHALATION:NOT EXPECTED TO BE A HAZARD DUE TO LOW VAPOR
PRESSURE. EYE CONTACT:MAY CAUSE SLIGHT IRRITATION. SKIN CONTACT:MAY
CAUSE SLIGHT IRRITATION.
Explanation of Carcinogenicity:NOT SPECIFIED
Effects of Overexposure:DIARRHEA, NAUSEA, IRRITATION.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INGESTION:DILUTE BY GIVING WATER; INDUCE VOMITING (ONLY IF
VICTIM IS CONSCIOUS). CALL PHYSICIAN. INHALATION: REMOVE TO FRESH
AIR. SKIN CONTACT: WASH THOROUGHLY WITH SOAP AND WATER. EYE
CONTACT:RINSE E YES WITH RUNNING WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point:=229.4C, 445.F
Lower Limits:N/D
Upper Limits:N/D
Extinguishing Media:FOAM, WATER SPRAY, DRY CHEMICAL, CO2.
Fire Fighting Procedures:FIREFIGHTERS SHOULD USE POSITIVE PRESSURE,
SELF-CONTAINED BREATHING APPARATUS. DO NOT SPRAY POOL FIRES WITH
DIRECT WATER STREAM.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK, DAM SPILL AND COLLECT WITH
ABSORBENT, PLACE IN OPEN CONTAINERS AND PLACE OUTSIDE.
Neutralizing Agent:NONE SPECIFIED
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY AREA. KEEP CONTAINER
CLOSED TO MAINTAIN PRODUCT QUALITY.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IN NORMAL USE
Ventilation:GENERAL MECHANICAL VENTILATION
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER USING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:<1MMHG
Vapor Density:>1
Spec Gravity:~1.02
Evaporation Rate & Reference:<<1 (BUAC=1)
Solubility in Water:LOW
Appearance and Odor:WATER WHITE LIQUID, LOW ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:TEMPERATURES ABOVE 300F
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
=================== Toxicological Information===================
Toxicological Information:NO INFORMATION PROVIDED.
===================== Ecological Information =====================
Ecological:NO INFORMATION PROVIDED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:NO INFORMATION PROVIDED.
===================== Regulatory Information =====================
SARA Title III Information:SEC 311/312 REPORTABLE MATERIAL= NONE. SEC
313: THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS SUBJECT TO
THE REQUIREMENTS OF SEC 313 OF EPCRA (40CFR 372): NONE.
Federal Regulatory Information:THE INGREDIENTS OF THIS PRODUCT ARE ON
THE TSCA INVENTORY.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:27889-0250 4-IODOACETOPHENONE 98% 82228
CAGE:GO713
CAGE:GO713
============= Composition/Information on Ingredients =============
Ingred Name:4'-IODOACETOPHENONE
CAS:13329-40-3
Fraction by Wt: 98%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:USE APPROPRIATE PROCEDURES TO PREVENT
DIRECT CONTACT W/THE SKIN/EYES/INHALATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:USE APPROPRIATE PROCEDURES TO PREVENT DIRECT
CONTACT W/SKIN/EYES/INHALATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: FLUSH
W/PLENTY OF SOAP & WATER FOR 15 MINS. INGESTION: IF CONSCIOUS &
ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. INHALATION: REMOVE TO FRESH
AIR. GIVE CPR/ OXYGEN IF NEEDED. NOTES TO PHYSICIAN: TREAT
SYMPTOMATICALLY & SUPPORTIVELY. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE AGENT MOST APPROPRIATE TO EXTINGUISH FIRE.
Fire Fighting Procedures:WEAR SCBA IN PRESSURE DEMAND MSHA/NIOSH
APPROVED/EQUIVALENT & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:DURING A FIRE, IRRITATING & HIGHLY TOXIC
GASES MAY BE GENERATED BY THERMAL DECOMPOSITION/COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP IMMEDIATELY, OBSERVE PRECAUTIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORE IN A COOL, DRY PLACE.
Other Precautions:AVOID INGESTION & INHALATION. AVOID CONTACT W/EYES,
SKIN & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A RESPIRATORY PROTECTION PROGRAM THAT MEETS
OSHA'S REQUIREMENTS MUST BE FOLLOWED WHENEVER CONDITIONS WARRANT A
RESPIRATOR'S USE.
Ventilation:LOCAL EXHAUST TO CONTROL AIRBORNE LEVELS.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE MATERIALS, STRONG OXIDANTS.
Hazardous Decomposition Products:IRRITATING & TOXIC FUMES & GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ZEP STRIP-EASE #1071 (WAX STRIPPER)
CAGE:27674
CAGE:27674
============= Composition/Information on Ingredients =============
Ingred Name:MONOETHANOLAMINE
CAS:141-43-5
RTECS #:KJ5775000
Fraction by Wt: 20-30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3 PPM/STEL 6 PPM
ACGIH TLV:3 PPM/STEL 6 PPM
Ingred Name:ETHYLENE GLYCOL MONOBUTYL ETHER (SARA 313)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 20-30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM (SKIN)
ACGIH TLV:25 PPM
Ingred Name:TETRASODIUM ETHYLENE DIAMINE TETRAACETATE
CAS:64-02-8
RTECS #:AH5075000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISOPROPYL ALCOHOL (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM/STEL 500 PPM
ACGIH TLV:400 PPM/STEL 500 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT EST.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CONCENTRATE MAY BE CORROSIVE TO
EYES/MUCOUS MEMBRANES, SOLUTIONS ARE SEVERE EYE IRRIT. EYES - MAY
RESULT IN CORNEAL DAMAGE/BLINDNESS. SKIN - MAY PRODUCE IRRITATION
DEPENDING LENGTH OF CONTACT T IME. INHAL: OVEREXPOSURE MAY CAUSE
RESPIRATORYIRRIT. CHRONIC: REPEATED/PROLONGED SKIN EXPOSURE CAN
PRODUCE CHRONIC
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS ARE LISTED AS
CARCINOGENS BY IARC, NTP, OSHA.
Effects of Overexposure:NK *DERMATITIS - REDNESS, SCALING, BLISTERING.
REPEATED EXPUSURE TO SPRAY MISTS MAY LEAD TO CHRONIC EYE
INFLAMMATION, RESPIRATORY IRRITATION OR LUNG DAMAGE. ANIMAL STUDIES
INDICATE POTENTIAL FOR LIVE R, KIDNEY, RED BLOOD CELL DAMAGE.
RELEVANCE OF THESE STUDIES FOR HUMANS NOT ESTABLISHED.
Medical Cond Aggravated by Exposure:INGREDIENTS IN THIS PRODUCT MAY
AGRAVATE EXISTING SKIN, EYE, RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:SKIN: IMMEDIATELY FLUSH CONTAMINATED SKIN W/PLENTY WATER AT
LEAST 15 MINUTES. GET MED AID IF IRRITATION DEVELOPS. EYES: IMMED
FLUSH W/PLENTY WATER AT LEAST 15 MINUTES, OCCASIONALLY LIFTING
LIDS. GET M EDICAL AID AT ONCE. INHAL: GET FRESH AIR. IF IRRITATION
PERSISTS GET MEDICAL AID PROMPTLY. INGESTION: DON'T INDUCE
VOMITING. IF VICTIM CONSCIOUS GIVE PLENTY WATER TO DRINK. GET
MEDICAL AID AT ONCE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:136F,58C
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NONCOMBUSTIBLE
Fire Fighting Procedures:POSITIVE PRESSURE SCBA.
Unusual Fire/Explosion Hazard:FIRE-EXPOSED DRUMS SHOULD BE COOLED
W/STREAM OF WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON INERT ABSORBENT MAT'L (E.G.
ZEP-O-ZORB). OBSERVE HANDLING/STORAGE/PROTECTIVE MEASURES AS LISTED
BELOW. PICK UP/PLACE IN CLEAN DOT SPEC CONTAINER FOR DISPOSAL. WASH
AREA THOROUGHLY W/DETERGEN T SOLUTION THEN RINSE WELL W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:COMBUSTIBLE! STORE/USE AWAY FROM
HEAT/SPARKS/OPEN FLAME & ANY IGNITION SOURCES. DO NOT BREATHE
SPRAY/MISTS/VAPORS. KEEP AWAY FROM CHILDREN, SKIN, EYES
Other Precautions:CLOTHING/SHOES THAT BECOME CONTAMINATED W/SUBSTANCE
SHOULD BE REMOVED PROMPTLY, NOT REWORN UNTIL THOROUGHLY CLEANED.
KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO EXTRA MEASURES NEEDED IF VENTILATION
ADEQUATE.
Ventilation:PROVIDE LOCAL EXHAUST/VENT AS NEEDED TO KEEP VAPOR
CONCENTRATIONS <PEL & TLV
Supplemental Safety and Health
CONTACT EXPECTED. **TIGHT-FITTING SAFETY GLASSES RECOMMENDED IF
SPLASHING MAY OCCUR.
================== Physical/Chemical Properties ==================
Spec Gravity:0.98
pH:12.1 C
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID W/BUTYL ODOR
Percent Volatiles by Volume:98
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ALKALIES, OXIDIZERS.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE, OTHER
UNIDENTIFIED ORGANIC COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:LIQ NOT PERMITTED IN LANDFILLS UNLESS
SOLIDIFIED. MAY NEED DISPOSE UNUSABLE PROD/SPENT USE-DILUTIONS AT
HAZ WASTE TREATMENT/STORAGE/DISPOSAL FACILITY. SOME STATES
CHEM/WASTE LANDFILL OKAY. SOME AREAS FLUSHING TO SEWER OK. SEE
LAWS FOR YOURAREA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SPACKLING POWDER
Preparer's Name:STEVE TAYLOR
CAGE:CUSTO
CAGE:CUSTO
============= Composition/Information on Ingredients =============
Ingred Name:PLASTER OF PARIS; (GYPSUM)
CAS:26499-65-0
RTECS #:TP0700000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:NUISANCE DUST, MAY
CAUSE IRRITATION TO UPPER RESPIRATORY TRACT. SKIN & EYE CONTACT:A
LARGE MASS MAY CAUSE BURNS IF IN CONTACT W/SKIN WHILE HARDENING.
SKIN ABSORPTION:MAY CAUSE IRRITAT ION. INGESTION:WILL HARDEN
W/WATER. IF INGESTED MAY RESULT IN OBSTRUCTION. CHRONIC:NONE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGESTION:SEE MD. EYES:FLUSH W/WATER FOR AT LEAST 15 MINUTES.
IF IRRITATION PERSISTS, CONSULT MD. SKIN:FLUSH W/WATER.
INHALATION:REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP & PUT IN APPROVED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A DRY AREA. USE ADEQUATE
VENTILATION TO MINIMIZE DUST EXPOSURE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATORS FOR NUISANCE
DUSTS.
Ventilation:TO CONTROL DUST.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:GOOD HOUSEKEEPING PRACTICES SHOULD BE USED.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:2.5 (H*2O=1)
Solubility in Water:SLIGHT SOLUBILITY
Appearance and Odor:LIGHT COLORED TO WHITE POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, ALUM, AMMONIUM SALTS, MERCURY & HYDROGEN.
Stability Condition to Avoid:ACIDS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCES CALCIUM
OXIDE. REACTION W/ACIDS PRODUCE CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS ANY INERT POWDER. DISPOSE I/A/W
FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FA1051 MMM-A-1617 TYPE 11
Preparer's Name:ERNEST CARTER
CAGE:GO659
CAGE:GO659
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE
CAS:110-54-3
RTECS #:MN9275000
= Wt:25.
OSHA PEL:1800 MG/M3;500 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:METHYL ETHYL KETONE
CAS:78-93-3
RTECS #:EL6475000
= Wt:13.
OSHA PEL:590 MG/M3;200 PPM
ACGIH TLV:590 MG/M3;200 PPM
ACGIH STEL:885 MG/M3;300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
= Wt:18.
OSHA PEL:2400 MG/M3;1000 PPM
ACGIH TLV:1780 MG/M3;750 PPM
ACGIH STEL:2380 MG/M3;1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:POLYCHLOROPRENE SYNTHETIC RUBBER
CAS:9010-98-4
Code:F
RTECS #:EI9640000
Ingred Name:TOLUENE
CAS:108-88-3
Code:F
RTECS #:XS5250000
= Wt:16.
OSHA PEL:SEE TABLE Z-2
ACGIH TLV:188 MG/M3;50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:MUCOUS IRRITATION TO EYES AND MEMBRANES. DRY
CRACKED SKIN, LIQUID INGESTION MAY RESULT IN VOMITING. CAN CAUSE
SEVERE EYE BURNS TINGLING AND WEAKNESS OF ARMS AND LEGS MAY OCCUR.
Medical Cond Aggravated by Exposure:RESPIRATORY ALIMENTS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATEREYES: FLUSH EYES ABUNDANTLY
WITH CLEAN WATER.. INGESTION: DO NOT INDUCE VOMITING.
INHALATION: REMOVE PATIENT TO FRESH AIR OR GIVE OXYGEN
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:1.0
Upper Limits:12.8
Extinguishing Media:: CO2, FOAM, AND DRY CHEMICAL
Fire Fighting Procedures:NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING
APPARATUS SHOULD BE WORN.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND MAY TRAVEL
CONSIDERABLE DISTANCE TO A SOURCES OF IGNITION AND FLASHBACK
================== Accidental Release Measures ==================
Spill Release Procedures:ABSOB SPILL IN SAND, EARTH, VERMICULITE,
OIL-DRI, OR SOL-SPEED-DRI.SHOVEL ABSORBED MATERIAL INTO STEEL
CONTAINER AND COVER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED AND
STORE IN APPROVED SOLVENT STORAGE AREA. KEEP AWAY FROM OPEN FLAME,
HEAT SPARKS, HOT SURFACES AND OXIDIZING AGENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED ATMOSPHERE SUPPLYING OR AIR
PURIFYING RESPIRATOR.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO PREVENT
SKIN CONTACT.
Work Hygienic Practices:KEEP AREA CLEAN. CLEAN UP SPILLS IMMEDIATELY.
PRACTICE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=55.6C, 132.F
Vapor Pres:116.6 AT20 DEG.C OR 68 F
Vapor Density:2.64
Spec Gravity:0.828
VOC Pounds/Gallon:627
VOC Grams/Liter:7.08
Appearance and Odor:SWEET SOLVENTY PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AVOID HEAT, OPEN FLAMES, SPARKS, HOT
SURFACES AND OXIDIZING AGENTS.
Hazardous Decomposition Products:OXIDES OF CARBON, MAGNESIUM, ZINC,
HYDROGEN CHLORIDE. HAZARDOUS
Conditions to Avoid Polymerization:: WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL CHEMICAL AND SOLVENT WASTE DISPOSAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:THIONYL CHLORIDE 0246
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:THIONYL CHLORIDE
CAS:7719-09-7
RTECS #:XM5150000
Fraction by Wt: 100%
OSHA PEL:C 1 PPM
ACGIH TLV:C 1 PPM; 9192
===================== Hazards Identification =====================
Effects of Overexposure:SKIN/EYES:IRRITNT,CORROSIVE,MAY CAUSE EYE
BURNS;INHALE:IRRITNT,MAY CAUSE PUMONARY EDEMA.
======================= First Aid Measures =======================
First Aid:INHALE:EMOVE TO FRESH AIR,GIVE CPR/O*2 IF NEED;EYES:FLUSH W
LG AMTS H*2O FOR 15 MIN;SKIN:FLUSH W LG AMTS H*2O;INGEST:RINSE
MOUTH,GIVE EXCESS OF WATER,GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CNTND BRTHG APP;H*2O SPRAY COOL
CONT, IF INTACT.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE IN HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS.STOP LEAK. H*2O
SPRAY COOL CONT IF FIRE/HEAT.PROVIDE VENTILATION.COVER SPILL W
SODIUM BICARBONATE,CAUTIOUSLY MIX & SPRAY W H*2O TO NEUTRALIZE.HOLD
IN CONTAINER PENDING DIS POSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED,LOW
FIRE RISK AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL
CONTACT.KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:AVOID PROLONGED OR REPEATED CONTACT W CHEMICAL.REMOVE
& WASH CONTAMINATED CLOTHING.MAINTAIN STRICT HYGIENE. *W
WATER,SCOOP UP & ADD TO LG VOLUME OF H*2O, THEN SEWER(IF APPROVED).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR SELF-CNTND BRTHG APP OR AIR SUPPLIED FACE
MASK
Ventilation:MECHANICAL(GEN./LOCAL EXHAUST),WITH FUME HOOD WHEN USING.
Other Protective Equipment:NORMAL FULL WORK CLOTHING COVERING
ARMS,LEGS,FACE SHIELD,ETC
Supplemental Safety and Health
MSDS FROM MFG.DATED 10/6/72.PRODUCT IS HYDROLIZED IN WATER TO SO*2 &
HCL.NOTE THAT FUMES FROM PRODUCT ARE CHLORINE AND SULFUR
DIOXIDE,TLV OF SO*2 IS 2 PPM AND OF CL*2 IS 1 PPM.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:174F,79C
Vapor Pres:97
Vapor Density:4.1
Spec Gravity:1.64
Solubility in Water:SEE SUP DAT
Appearance and Odor:COLORLESS,FUMING LIQUID;SUFFOCATING ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER,ALKALI
Stability Condition to Avoid:MOISTURE(FORMS H*2SO*4 & HCL, HIGHLY
CORROSIVE TO METALS)
Hazardous Decomposition Products:HYDROGEN CHLORIDE AND SULFUR
DIOXIDE(CORROSIVE,TOXIC VAPORS)
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL.HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE,& LOCAL REGULATIONS.MFG SUGGESTS
FURTHER NEUTRALIZATION BY ADDITION TO 50/50 DRY SODA ASH/SLAKED
LIME,SPRAY*(SEE OTHPRECAT)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:OXYGEN, COMPRESSED GAS
Kit Part:=== Responsible Party ===
780-471-4036
780-471-4036
CAGE:Company Name:MATHESON TRI-GAS, INC.
780-471-4036
CAGE:
============= Composition/Information on Ingredients =============
Ingred Name:OXYGEN, COMPRESSED GAS
CAS:7782-44-7
Fraction by Wt: 100.0%
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:No IARC:NoOSHA:No
Health Hazards Acute and Chronic:INHALATION: SHORT TERM EXPOSURE:
irritation, nausea, asthma, irregular heartbeat, dizziness,
tingling sensation, dilated pupils, blindness, lung congestion,
blood disorders, convulsions LONG TERM EXPOSURE: chest pain, lung
damage SKIN CONTACT: SHORT TERM EXPOSURE: no information on
significant adverse effects LONG TERM EXPOSURE: no information on
significant adverse effects EYE CONTACT: SHORT TERM EXPOSURE:
irritation LONG TERM EXPOSURE: no information on significant
adverse effects INGESTION: SHORT TERM EXPOSURE: no information on
significant adverse effects LONG TERM EXPOSURE: no information is
available
Medical Cond Aggravated by Exposure:
======================= First Aid Measures =======================
First Aid: INHALATION: If adverse effects occur, remove to
uncontaminated area. Give artificial respiration if not breathing.
Get immediate medical attention. SKIN CONTACT: Wash exposed skin
with soap and water. EYE CONTACT: Wash eyes immediately with large
amounts of water, occasionally lifting upper and lower lids, until
no evidence of chemical remains. Get medical attention immediately.
INGESTION: If a large amount is swallowed, get medical attention.
===================== Fire Fighting Measures =====================
Extinguishing Media:carbon dioxide, regular dry chemical Large fires:
Use regular foam or flood with fine water spray.
Fire Fighting Procedures:Move container from fire area if it can be
done without risk. Cool containers with water spray until well
after the fire is out. Stay away from the ends of tanks. For fires
in cargo or storage area: Cool containers with water from unmanned
hose holder or monitor nozzles until well after fire is out. If
this is impossible then take the following precautions: Keep
unnecessary people away, isolate hazard area and deny entry. Let
the fire burn. Use extinguishing agents appropriate for surrounding
fire. Cool containers with water. Apply water from a protected
location or from a safe distance.
Unusual Fire/Explosion Hazard:Negligible fire hazard. Oxidizer. May
ignite or explode on contact with combustible materials. Containers
may rupture or explode if exposed to heat.
================== Accidental Release Measures ==================
Spill Release Procedures:Stop leak if possible without personal risk.
Avoid contact with combustible materials. Keep unnecessary people
away, isolate hazard area and deny entry. Ventilate closed spaces
before entering.
Neutralizing Agent:
======================Handling and Storage ======================
Handling and Storage Precautions:Store and handle in accordance with
all current regulations and standards. Subject to storage
regulations: U.S. OSHA 29 CFR 1910.101. Keep separated from
incompatible substances.
Other Precautions:
============= Exposure Controls/Personal Protection =============
Respiratory Protection:Under conditions of frequent use or heavy
exposure, respiratory protection may be needed. Respiratory
protection is ranked in order from minimum to maximum. Consider
warning properties before use. For Unknown Concentrations or
Immediately Dangerous to Life or Health - Any supplied-air
respirator with full facepiece and operated in a pressure-demand or
other positive-pressure mode in combination with a separate escape
supply. Any self-contained breathing apparatus with a full
facepiece.
Ventilation:Provide local exhaust ventilation system. Ensure compliance
with applicable exposure limits.
Other Protective Equipment:Protective clothing is not required.
Supplemental Safety and Health
OXYGEN, COMPRESSED GAS: No occupational exposure limits established.
================== Physical/Chemical Properties ==================
Boiling Pt:-297 F (-183 C)
Melt/Freeze Pt:-360 F (-218 C)
Vapor Pres:760 mmHg @ -183 C
Vapor Density:1.1
Spec Gravity:Not applicable
pH:Not applicable
Evaporation Rate & Reference:Not applicable
Solubility in Water:3.2% @ 25 C
Appearance and Odor:PHYSICAL STATE:gas COLOR:colorless ODOR:odorless
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:Stable at normal temperatures
and pressure.
Stability Condition to Avoid:Avoid contact with combustible materials.
Protect from physical damage and heat. Containers may rupture or
explode if exposed to heat.
Hazardous Decomposition Products:Thermal decomposition products:
miscellaneous decomposition products Thermal decomposition
products: miscellaneous decomposition products
Conditions to Avoid Polymerization:Will not polymerize.
=================== Toxicological Information===================
Toxicological Information:OXYGEN, COMPRESSED GAS: MUTAGENIC DATA:
Available. REPRODUCTIVE EFFECTS DATA: Available. OXYGEN,
COMPRESSED GAS: MUTAGENIC DATA: Available. REPRODUCTIVE EFFECTS
DATA: Available.
===================== Ecological Information =====================
Ecological:Not available
==================== Disposal Considerations ====================
Waste Disposal Methods:Dispose in accordance with all applicable
regulations. Subject to disposal regulations: U.S. EPA 40 CFR 262.
Hazardous Waste Number(s): D001.
=================== MSDS Transport Information ===================
Transport Information:U.S. DOT 49 CFR 172.101: PROPER SHIPPING NAME:
Oxygen, compressed ID NUMBER: UN1072 HAZARD CLASS OR DIVISION: 2.2
LABELING REQUIREMENTS: Nonflammable gas; Oxidizer
===================== Regulatory Information =====================
SARA Title III Information: SARA TITLE III SECTION 302 EXTREMELY
HAZARDOUS SUBSTANCES (40 CFR 355.30): Not regulated. SARA TITLE
III SECTION 304 EXTREMELY HAZARDOUS SUBSTANCES (40 CFR 355.40): Not
regulated.SARA TITLE III SARA SECTIONS 311/312 HAZARDOUS
CATEGORIES (40 CFR 370.21): ACUTE: No CHRONIC: No FIRE: Yes
REACTIVE: No SUDDEN RELEASE: Yes SARA TITLE III SECTION 313 (40
CFR 372.65): Not regulated.
Federal Regulatory Information:CERCLA SECTIONS 102a/103 HAZARDOUS
SUBSTANCES (40 CFR 302.4): Not regulated. OSHA PROCESS SAFETY
(29CFR1910.119): Not regulated.
State Regulatory Information: California Proposition 65: Not regulated.
======================= Other Information =======================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:128 2839 RAPID FIXER,PART A
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 40 - 45%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 40 - 45%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM ACETATE
CAS:127-09-3
RTECS #:AJ4300010
Fraction by Wt: 5 - 10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG BORATES/M3
ACGIH TLV:5 MG BORATES/M3
Ingred Name:AMMONIUM SULFITE (CERCLA)
CAS:10196-04-0
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID (CERCLA)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS >2540 MG/KG.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Effects of Overexposure:TRANSIENT EYE IRRITATION
Medical Cond Aggravated by Exposure:ASTHMATIC OR SULFITE-SENSITIVE
INDIVIDUALS MAY EXPERIENCE WHEEZING, CHEST TIGHTNESS, STOMACH
UPSET, HIVES, FAINTNESS, WEAKNESS AND DIARRHEA
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. EYES:FLUSH WITH WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN.
SKIN:WASH WITH SOAP & WATER. ORAL:IF CONSCIOUS, DRINK 1-2 GLASSES
OF WATE R. SEEK MEDICAL ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO
AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNT OF WATER.
OTHERWISE, ABSORB SPILL WITH INERT MATERIAL SUCH AS VERMICULITE,
THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CO NTAMINATION.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLE
MATERIALS. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID EYE CONTACT. USE
WITH ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
KEY1:N1. SEE NIIN 01-354-7466 FOR PART B. SEE PNI W/X FOR WORKING
SOLUTION. ECOLOGICAL INFORMATION: A MODERATE BIOCHEMICAL OXYGEN
DEMAND, A MODERATE POTENTIAL TO AFFECT AQUATIC ORGANISMS. AFTER
DILUTI ON WITH LARGE AMOUNT OF WATER, FOLLOWEDBY WASTE TREATMENT,
IT IS NOT EXPECTED TO CAUSE ADVERSE ENVIRONMENTAL EFFECTS.
================== Physical/Chemical Properties ==================
HCC:C1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18 @ 68F
Vapor Density:0.6
Spec Gravity:1.32
pH:5.0
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID - SLIGHT SULFUR DIOXIDE, ACETIC
ACID ODOR
Percent Volatiles by Volume:40- 45
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, STRONG ACIDS, STRONG OXIDIZING AGENTS, SODIUM HYPOCHLORITE.
CONTACT WITH BASE LIBERATES FLAMMABLE MATERIAL.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:OXIDES OF NITROGEN, SULFUR DIOXIDE,
CHLORAMINE, AMMONIA
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL REGULATIONS. FLUSH TO SEWER WITH LARGE
AMOUNT OF WATER, IF PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TAPE DRIVE CLEANING KIT/TEXPADS,TX511B/TX801,75-1110-511
Preparer's Name:NONE
CAGE:IO792
CAGE:21994
CAGE:IO792
CAGE:49269
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 91.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9394
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: IRRITATION, BURNING
SENSATION, EYE DAMAGE. SKIN: STINGING, BURNING SENSATION,
DEFATTING, IRRITATION. INHALATION: IRRITATION OF NOSE AND THROAT,
NARCOSIS, NAUSEA, HEADACHE. INGESTION: PROD UCT IS CONSIDERED A
POISON. INGESTION OF20ML WILL CAUSE SERIOUS ILLNESS; 250ML IS
LETHAL. CHRONIC: NONE SPECIFIED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION, BURNING SENSATION, EYE
DAMAGE. SKIN: IRRITATION, STINGING, BURNING, DEFATTING. INHALATION:
NOSE AND THROAT IRRITATION, NARCOSIS, NAUSEA, HEADACHE. INGESTION:
SERIOUS ILLNESS, DEATH.
Medical Cond Aggravated by Exposure:NONE LISTED.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. FLUSH AREA WITH
WATER. INHALATION: MOVE TO FRESH AIR. RESTORE/SUPPORT BREATHING AS
NEEDED. GIVE OXYG EN IF BREATHING IS DIFFICULT. GET MEDICAL
ATTENTION IF NEEDED. INGESTION: DRINK WATER TO DILUTE. IF MEDICAL
HELP IS READILY AVAILABLE, INDUCE VOMITING. GET MEDICAL HELP.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:60.0F,15.6C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICALS OR ALCHOL FOAM.
Fire Fighting Procedures:WATER MAY BE USED TO COOL FIRE EXPOSED
CONTAINERS, FINE WATER MIST MAY BE USED TO SMOTHER OR DISPERSE
VAPORS.
Unusual Fire/Explosion Hazard:LIQUID MAY RELEASE FLAMMABLE VAPORS WHICH
CAN IGNITE AT OR ABOVE FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN LARGE SPILLS, COLLECT LIQUID OR ABSORB
WITH ABSORBENT AND PLACE INTO COVERED CONTAINER FOR DISPOSAL. USE
NON-SPARKING TOOLS. WATER SPRAY CAN BE USED TO DILUTE AND FLUSH
SPILL. DO NOT FLUSH TO WATER COURSE OR TO SEWER OR ENCLOSED AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLEAN, COOL, VENTILATED AREA
AWAY FROM SOURCES OF IGNITION AND OXIDIZING AGENTS. HANDLE AND
STORE AS AN OSHA CLASS 1B FLAMMABLE LIQUID.
Other Precautions:CODED ELECTRICAL SERVICES REQUIRED. USE WITH ADEQUATE
VENTILATION. AVOID INHALING VAPORS AND PROLONGED CONTACT WITH
LIQUID. DO NOT TAKE INTERNALLY. DO NOT SMOKE OR EAT IN AREAS OF
STORAGE OR USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:ADEQUATE TO MAINTAIN TLVS.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
TEXPAD IS A PRESATURATED PAD CONTAINING A HYDROALCOHOLIC MIXTURE. THE
QUANTITY OF HAZARDOUS MATERIAL PER PACKAGE (PRESATURATED TOWELETTE)
IS ONLY 3.2 ML (2.5 G). ALL HAZARD DATA SHOULD BE REVIEWED ACC
ORDINGLY.
================== Physical/Chemical Properties ==================
HCC:F1
Boiling Pt:B.P. Text:81.5F,27.5C
Vapor Pres:43
Vapor Density:>1
Spec Gravity:0.818
Evaporation Rate & Reference:>1.0 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID. ALCOHOL ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAUSTICS, AMINES, ALKANOLAMINES, ALDEHYDES, AMMONIA, STRONG OXIDIZING
AGENTS AND CHLORINATED COMPOUNDS.
Stability Condition to Avoid:OPEN FLAMES, SPARKS, IGNITION SOURCES.
Hazardous Decomposition Products:THERMAL-OXIDATIVE DEGRADATION MAY
PRODUCE CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. IF PERMITTED, BURN WASTE LIQUID IN AN
APPROVED INCINERATOR OR DISPOSE VIA LICENSED DISPOSAL COMPANY.
ABSORBED WASTE CAN BE LAN DFILLED.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:PACKAGED CHAFF (ALUMINIZED GLASS), MK 214 MOD 0
CAGE:7L547
CAGE:7L547
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM (SARA 313)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 40%
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST
Ingred Name:FIBROUS GLASS; (GLASS)
RTECS #:LK3651000
Fraction by Wt: 60%
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:COATED FIBERS MAY BE SLIGHTLY
ABRASIVE TO SKIN, EYES AND MUCOUS MEMBRANES. OVEREXPOSURE MAY CAUSE
MINOR EYE IRRITATION IF FIBER GETS INTO EYES. CHRONIC:OVEREXPOSURE
IS PREVENTED BY INSURING FIBE RS DO NOT ENTER EYES. REPEATED
EXPOSURETO HANDS/ARMS HAS INFREQUENTLY CAUSED MINOR DERMATITIS &
MAY BE PREVENTED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . SKIN:FLUSH W/COPIOUS
AMOUNTS OF WATER. CALL MD . EYES:FLUSH W/SALINE SOLUTION OR WATE R
FOR AT LEAST 15 MINUTES TO IRRIGATE EYE TO REMOVE FIBER.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NO FIRE OR EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:UNLESS THERE IS CLOSE OR REPEATED
EXPOSURE TO FIBERS, NO PRECAUTIONS ARE NECESSARY.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . LIGHT COTTON SMOCK/LONG SLEEVE SHIRT MAY BE WORN TO PVNT
(SUPDAT)
Work Hygienic Practices:FIBERS MAY BE READILY REMOVED FROM HANDS BY
WATER OR PRESSURIZED AIR STREAM.
Supplemental Safety and Health
% VOLAT:NON-VOLATILE. OTHER PROT EQUIP:BODILY CONTACT IF DESIRED.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1250F,677C
Solubility in Water:NOT SOLUBLE
Appearance and Odor:FIBERS ARE SILVER (ALUMINUM) COLORED.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NOT REACTIVE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS ALLOWED BY FEDERAL, STATE & LOCAL
LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LEAD-ACID BATTERY
CAGE:20038
Contract Num:SP0430-01-M-FS55
CAGE:OFGN2
CAGE:20038
============= Composition/Information on Ingredients =============
Ingred Name:INORGANIC COMPOUNDS OF : LEAD
CAS:7439-92-1
RTECS #:OF7525000
= Wt:53.
Other REC Limits:NIOSH: 100UG/M3
OSHA PEL:50 UG/M3
ACGIH TLV:150 UG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:INORGANIC COMPOUNDS OF: ANTIMONY
CAS:7440-36-0
RTECS #:CC4025000
= Wt:.2
OSHA PEL:500 UG/M3
ACGIH TLV:500 UG/M3
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:INORGANIC COMPOUNDS OF: TIN
CAS:7440-31-5
RTECS #:XP7320000
= Wt:.06
OSHA PEL:2000 UG/M3
ACGIH TLV:2000 UG/M3
Ingred Name:INORGANIC COMPOUNDS OF: CALCIUM
CAS:7440-70-2
RTECS #:EV8040000
= Wt:.02
Ingred Name:INORGANIC COMPOUNDS OF: ARSENIC
CAS:7440-38-2
RTECS #:CG0525000
= Wt:.01
OSHA PEL:10 UG/M3
ACGIH TLV:2000 UG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ELECTROLYTE (SULFURIC ACID/WATER/SOLUTION)
CAS:7664-93-9
RTECS #:WS5600000
Minumum % Wt:30.
Maxumum % Wt:40.
Other REC Limits:NIOSH: 1000 UG/M3
OSHA PEL:1000 UG/M3
ACGIH TLV:1000 UG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CASE MATERIAL: POLYPROPYLENE
CAS:9003-07-0
RTECS #:UD1842000
Minumum % Wt:5.
Maxumum % Wt:6.
Ingred Name:CASE MATERIAL: HARD RUBBER
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY MANUFACTURER
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: ELECTROLYTE (WATER AND SULFURIC
ACID SOLUTION): SEVERE SKIN IRRITATION, DAMAGE TO CORNEA MAY CAUSE
BLINDNESS, UPPER RESPIRATORY IRRITATION. LEAD COMPOUNDS: SYMPTOMS
OF TOXICITY INCLUDE HEADACHE , FATIGUE, ABDOMINAL PAIN, LOSS OF
APPETITE, MUSCULAR ACHES AND WEAKNESS, SLEEP DISTURBANCES AND
IRRITABILITY. CHRONIC: ELECTROLYTE (WATER AND SULFURIC ACID
SCOLUTION): POSSIBLE EROSION OF TOOTH ENAME L; INFLAMMATION OF
NOSE, THROAT AND BRONCHIAL TUBES. LEAD COMPOUNDS: ANEMIA;
NEUROPATHY, PARTICULARLY OF THE MOTOR NERVES, WITH WRIST DROP;
KIDNEY DAMAGE; REPRODUCTIVE CHANGES IN BOTH MALES AND FEMALE S.
Explanation of Carcinogenicity:THE IARC HAS CLASSIFIED "STRONG
INORGANIC ACID MOST CONTAINING SULFURIC ACID" AS A CATEGORY I
CARCINOGEN, A SUBSTANCE THAT IS CARCINOGENIC TO HUMAN. LEAD
COMPOUNDS - LISTED AS A 2B CARCINOGEN.
Effects of Overexposure:INHALATION: ELECTROLYTE-BREATHING OF SULFURIC
ACID VAPORS/MISTS MAY CAUSE SEVERE RESPIREATORY IRRITATION.
LEAD-INHALATION OF LEAD DUSTS OR FUMES MAY CAUSE IRRITATION OF
UPPER RESPIRATORY TRACT & LUNGS . INGESTION: ELECTROLYTE-MAY CAUSE
SEVERE IRRITATION OF MOUTH, THROAT, ESOPHAGUS & STOMACH. LEAD-ACUTE
INGESTION MAY CAUSE ABDOMINAL PAIN, NAUSEA, VOMITING, DIARRHEA &
SEVERE CRAMPING. THIS MAY LEAD R APIDLY TO SYSTEM TOXICITY. SKIN:
ELECTROLYTE-SEVERE IRRITATION, BURNS & ULCERATION. LEAD-NOT
ABSORBED THROUGH THE SKIN. EYE-ELECTROLYTE: SEVERE IRRITATION,
BURNS, CORNEA DAMAGE, BLINDNESS. LEAD-MAY CA USEE EYE IRRITATION.
Medical Cond Aggravated by Exposure:OVEREXPOSURE TO SULFURIC ACID MIST
MAY CAUSE LUNG DAMAGE & AGGRAVATE PULMONARY CONDITIONS. CONTACT OF
SULFURIC ACID WITH SKIN MAY AGGRIVATE SKIN DISEASES SUCH AS ECZEMA
AND CONTACT DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: ELECTROLYTE-REMOVE TO FRESH AIR IMMEDIATELY. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. LEAD-REMOVE FROM EXPOSURE,
GARGLE, WASH NOSE & LIPS; CONSULT PHYSICIAN. INGESTION:
ELECTROLYTE-GIVE LAR GE QUANTITIES OF WATER, DO NOT INDUCE
VOMITING; CONSULT PHYSICIAN. LEAD-CONSULT PHYSICIAN IMMEDIATELY.
SKIN: ELECTROLYTE-FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES, REMOVE CONTAMINATED CLOTHING COMPLETELY, INLCUDING SHOES.
LEAD-WASH IMMEDIATELY WITH SOAP & WATER. EYES: ELECTROLYTE -FLUSH
IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR 15 MINS; CONSULT
PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NOT APPLICABLE.
Lower Limits:4.1%
Upper Limits:74..2%
Extinguishing Media:CO2, FOAM; DRY CHEMICAL.
Fire Fighting Procedures:USE POSITIVE PRESSURE, SELF-CONTAINED
BREATHING APPARATUS. BEWARE OF ACID SPLATTER DURING WATER
PROTECTION.IF BATTERIES ARE ON CHARG E, SHUT OFF POWER TO THE
CHARGING EQUIPMENT, BUT NOTE THAT BATTERIES STRINGED TOGETHER STILL
MAY POSE A RISK.
Unusual Fire/Explosion Hazard:IN OPERATION, BATTERIES GENERATE/RELEASE
FLAMMABLE HYDROGEN GAS. THEY MUST ALWAYS BE ASSUMED TO CONTAIN THIS
GAS WHICH, IF IGNITED BY BURNING CIGARETTE, NAKED FLAME/SPARK, MAY
CAUSE BATTERY EXPLOSION WITH DISPERSION OF CASING FRAGMENTS &
CORROSIVE LIQUID ELECTROLYTE. CAREFULLY FOLLOW MANUFACTURER INSTALL
INSTRUCTION.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP FLOW OF MATERIAL, CONTAIN/ABSORB SMALL
SPILL WITH DRY SAND, EARTH, VERMICULITE. DO NOT USE COMBUSTIBLE
MATERIALS.IF POSSIBLE, CAREFULLY NEUTRALIZE SPILLED ELECTROLYTE
WITH SODA ASH, SODIUM BIC ARBONATE, LIME, ETC. WEAR ACID-RESISTANT
UNNEUTRALIZED ACID TO SEWER. NEUTRAL ACID MUST BE MANAGED WITH
LOCAL, STATE & FEDERAL REGS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BATTERIES UNDER ROOF IN COOL,
DRY, WELL-VENTILATED AREAS WHICH ARE SEPERATED FROM INCOMPABILE
MATERIALS & FROM ACTIVITIES WHICH MAY CREATE FLAMES, SPARKS, OR
HEAT. STORE ON SMOOTH, IMPERVIOUS SU RFACES WHICH ARE PROVIDED
WITH MEAASURES FOR LIQUID CONTAINMENT IN THE EVENT OF ELECTROLYTE
SPILLS.
Other Precautions:KEEP AWAY FROM METALLIC OBJECTS WHICH COULD BRIDGE
THE TERMINALS ON A BATTERY & CREATE A DANGEROUS SHORT-CIRCUIT.
HANDLE CAREFULLY & AVOID TIPPING. SINGLE BATTERIES POSE NO RISK OF
ELECTRIC SHOCK BUTIF THER'S A STRING OF CONNECTED BATTERIES
EXCEEDING THREE 12-VOLTS, THE RISK MAY INCREASE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITIONS. WHEN
CONCENTRATIONS OF SULFURIC ACID MIST ARE KNOWN TO EXCEED PEL, USE
NIOSH OR MSHA-APPROVED RESPIRATORY PROTECTION.
Ventilation:STORE & HANDLE IN WELL-VENTILATED AREA. IF MECHANICAL
VENTILATION IS USED, COMPONENTS MUST BE ACID-RESISTANT.
ELBOW-LENGTH GAUNTLET.
Other Protective Equipment:ACID-RESISTANT APRON. UNDER SEVERE EXPOSURE
BOOTS.WEAR PROTECTIVE CLOTHING, EYE & FACE PROTECTION, WHEN
FILLING/HANDLING BATTERIES.
Work Hygienic Practices:HANDLE BATTERIES CAUTIOUSLY, DO NOT TIP TO
AVOID SPILLS. MAKE CERTAIN VENT CAPS ARE ON SECURELY. AVOID BODILY
CONTACT WITH INTERNAL COMPONENTS.
Supplemental Safety and Health
IN AREAS WHERE SULFURIC ACID IS HANDLED IN CONCENTRATIONS GREATER THAN
1%, EMERGENCY EYEWASH STATIONS AND SHOWERS SHOULD BE PROVIDED, WITH
UNLIMITED WATER SUPPLY.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:>95.C, 203.F
B.P. Text:203F-240F
Vapor Pres:17 TO 11 (FOR S.G. RANGE)
Vapor Density:>1
Spec Gravity:1.230-1.350
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:100%
Appearance and Odor:A CLEAR LIQUID WITH A SHARP, PENETRATING, PUNGENT
ODOR.
Percent Volatiles by Volume:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SULFURIC ACID: CONTACT WITH COMBUSTIBLES AND ORGANIC MATERIALS,
REDUCING AGENTS, METALS, SULFUR TRIOXIDE GAS, STRONG OXIDIZERS AND
WATER. CONTACT WITH METALS MAY PRODUCE TOXIC SULFUR DIOXIDE FUMES
AND MAY RELEASE FLAMMABLE
Stability Condition to Avoid:PROLONGED OVERCHARGE AT HIGH CURRENT
SOURCES OF IGNITION.
Hazardous Decomposition Products:SULFUR TRIOXIDE, CARBON MONOXIDE,
SULFIRIC ACID MIST, SULFUR DIOXIDE, HYDROGEN. TOXIC METAL FUMES,
VAPOR OR DUST.TOXIC ARSENIC GAS.
=================== Toxicological Information===================
Toxicological Information:IARC HAS CLASSIFIED :STRONG INORGANIC ACID
MIST CONTAINING SULFURIC ACID" AS A CATEGORY I CARCINOGEN, A
SUBSTANCE THAT IS CARCINOGENIC TO HUMANS. THIS CLASSIFICATION DOES
NOT APPLY TO SULFURIC ACID SO LUTIONS IN STATIC LIQUID STATE OR TO
ELECTROLYTE IN BATTERIES. BATTERIES SUBJECT TO ABUSIVE CHARGING AT
EXCESSIVELY HIGH CURRENTS FOR PROLONGED PERIODS OF TIME WITHOUT
VENT CAPS IN PLACE MAY CREATE A SURROUNDING ATMOSPHERE OF THE
OFFENSIVE STRONG INORGANIC ACID MIST CONTAINING SULFURIC ACID. LEAD
COMPOUND: LISTED AS 2B CARCINOGEN, LIKELY IN ANIMALS AT EXTREME
DOSES. PROOF OF CARCINOGENICITY IN HUM ANS IS CURRENTLY LACKING.
===================== Ecological Information =====================
Ecological:NO DATA PROVIDED BY MANUFACTURER
==================== Disposal Considerations ====================
Waste Disposal Methods:SPENT BATTERIES: SEND TO SECONDARY LEAD SMELTER
FOR RECYCLING. ELECTROLYTE: PLACE NEUTRAL SLURRY IN SEALED ACID
RESISTANT CONTAINER & DISPOSE OF AS HAZARDOUS WASTE, AS APPLICABLE.
LARGE WATER-DILUTED SPILL, AFTER NEUTRALISED & TESTED, SHOULD BE
MANAGED IN ACCORDANCE WITH APPROVED LOCAL, STATE & FED LAWS.
=================== MSDS Transport Information ===================
Transport Information:U.S. DOT: WET (FILLED WITH ELECTROLYTE) BATTERIES
ARE REGULATED BY U.S. DOT AS HAZARDOUS MATERIAL. PROPER SHIPPING
NAME: BATTERY, WET, FILLED WITH ACID. HAZARD CLASS/DIVISION: 8. ID
NUMBER: UN2794. PA CKING GROUP: III. LABEL REQUIRED: CORROSIVE.
(DLA-HMIS: PER SAMMS-CTSF THIS BATTERY/NSN IS WET, SPILLABLE).
===================== Regulatory Information =====================
SARA Title III Information:CERCLA (SUPERFUND) AND EPCRA: (A) REPORTABLE
QUANTITY (RQ) FOR SPILLED 100% SULFURIC ACID UNDER CERCLA
(SUPERFUND) AND EPCRA (EMERGENCY PLANNING AND COMMUNITY
RIGHT-TO-KNOW ACT) IS 1000 LBS. (B) SULFU RIC ACID IS A LISTED
"EXTREMELY HAZARDOUS SUBSTANCE" UNDER EPCRA, WITH A THRESHOLD
PLANNING QUANTITY (TPQ) OF 1000 LBS. (C) EPCRA SECTION 302
NOTIFICATION IS REQUIRED IF 1000 LBS OR MORE OF SULFURIC A CID IS
PRESENT AT ONE SITE. (D) EPCRA SECTION 312 TIER TWO REPORTING IS
REQUIRED IF ACID IS >=500 LBS, LEAD >=10000 LBS. (E) SUPPLIER
NOTIFICATION: CONTAINS TOXIC CHEMICALS REPORTABLE UNDER EPCRA SECT
ION 313:PB, H2SO4,SB, AS.
Federal Regulatory Information:RCRA: SPENT LEAD-ACID BATTERIES ARE NOT
REGULATED AS HAZARDOUS WASTE WHEN RECYCLED. SPILLED SULFURIC ACID
IS A CHARACTERISTIC HAZARDOUS WASTE; EPA HAZARDOUS WASTE NUMBER
D002 (CORROSIVITY). TSCA: INGR EDIENTS IN EXIDE`S BATTERIES ARE
LISTED IN THE TSCA REGISTRY AS FOLLOWS: SULFURIC ACID, LEAD, LEAD
OXIDE, LEAD SULFATE, ANTIMONY, ARSENIC, CALCIUM, TIN.
State Regulatory Information:CALIFORNIA PROPOSITION 65: WARNING: THIS
PRODUCT CONTAINS LEAD, A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:841 5580 EKTACOLOR RA DEVELOPER REPLENISHER RT, PART B
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 65-70%
Other REC Limits:NONE RECOMMENDED
Ingred Name:4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-
METHYLPHENYLENEDIAMINE SESQUISULFATE MONOHYDRATE
CAS:25646-71-3
RTECS #:PB0431000
Fraction by Wt: 20-25%
Other REC Limits:NONE RECOMMENDED
Ingred Name:LITHIUM SULFATE
CAS:10377-48-7
RTECS #:OJ6419000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 400 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LIBERATES SULFUR DIOXIDE GAS WHICH IS
IRRITATING TO RESPIRATORY TRACT. MAY CAUSE KIDNEY DAMAGE BASED ON
ANIMAL DATA. EYE CONTACT CAUSES IRRITATION. VAPOR IRRITATES EYES.
SKIN CONTACT CAUSES IRRITATION . MAY CAUSE ALLERGIC SKIN REACTION.
HARMFUL IF SWALLOWED. MAY CAUSE IRRITATION OF THE GASTROINTESTINAL
TRACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:RESPIRATORY TRACT IRRITATION, KIDNEY DAMAGE,
DIFFICULT BREATHING, EYE IRRITATION, SKIN IRRITATION, ALLERGIC SKIN
REACTION, GI TRACT IRRITATION.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS OR HYPERSENSITIVE
INDIVIDUALS MAY EXPERIENCE DIFFICULT BREATHING.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: INDUCE VOMITING AS DIRECTED BY MEDICAL PERSONNEL. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. CALL PHYSICIAN OR
POISON CONTROL ASAP.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NEUTRALIZATION AND SEWERING MAY NOT BE ALLOWED IN
SOME STATES AND MUNICIPALITIES
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING VAPOR. AVOID CONTACT
WITH EYES, SKIN & CLOTHING. KEEP FROM CONTACT WITH OXIDIZING
MATERIALS. KEEP AWAY FROM INCOMPATIBLE SUBSTANCES.
Other Precautions:USE WITH ADEQUATE VENTILATION. KEEP CONTAINER CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS, AN APPROVED
RESPIRATOR MUST BE WORN. RESPIRATOR TYPE: ACID GAS. IF RESPIRATORS
ARE USED, A PROGRAM SH OULD BE INSTITUTED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE. THIS IS PART B OF A
THREE-PART KIT. KEY1:C1.
================== Physical/Chemical Properties ==================
HCC:B2
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.15-1.17
pH:1.2
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT AMBER LIQUID, SHARP SULFUR DIOXIDE ODOR
Percent Volatiles by Volume:65-75%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STABLE.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN, OXIDES OF SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DYR6011J
CAGE:09023
CAGE:09023
CAGE:14655
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:377, COPPER BASE ALLOYS IN RODS, BARS, (SUP
CAGE:86924
CAGE:86924
============= Composition/Information on Ingredients =============
Ingred Name:ZINC (SARA III) (LIMITS GIVEN AS ZN OXIDE)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 0-43%
Other REC Limits:5 MG/M3;10 STEL FUME
OSHA PEL:10 MG/M3 TDUST;5RESP
ACGIH TLV:10 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 0-15%
OSHA PEL:15MG/M3 DUST;5 RESP
ACGIH TLV:10MG/M3 DUST;5 FUME
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 0-6%
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 0-5.5%
OSHA PEL:0.05 MG/M3
ACGIH TLV:0.15 MG/M3 DUST/FUME
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 0-5%
Other REC Limits:1 MG/M3;3 STEL FUME
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 0-33%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:PHOSPHOROUS (WHITE) (SARA III)
CAS:7723-14-0
RTECS #:TH3500000
Fraction by Wt: 0-0.5%
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 0-4.5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 0-11%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:TELLURIUM; (TELLURIUM COMPOUNDS) (SARA III)
CAS:13494-80-9
RTECS #:WY2625000
Fraction by Wt: 0-0.5%
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
Ingred Name:SUPDAT:IRRIT SKIN/EYES IN BULK FORM. PARTICULATES MAY CAUSE
DERM DUE TO MECHANICAL IRRIT.
RTECS #:9999999ZZ
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 45-100%
Other REC Limits:1 MG/M3 DUST/MIST
OSHA PEL:0.1MG/M3 FUME
ACGIH TLV:0.2MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:NOTE:LEAD (CAS #7439-92-1) APPEARS ON
THE NAVY LISTING OF OCCUP REPRO HAZS. SEEK CONSULTATION FROM APPROP
HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG &
EXPOS REC . UNDER NORM AL HNDLG CONDTNS SOLID ALLOY PRESENTS NO
SIGNIFICANT HLTH HAZ. PROCESSING OF ALLOY BY DUST/FUME (EFTS OF
OVEREXPOS)
Explanation of Carcinogenicity:NICKEL:GROUP 2B (IARC), ANTICIPATED TO
BE A CARCINOGEN (NTP). LEAD:GROUP 2B (IARC).
Effects of Overexposure:HLTH HAZ:PRODUCING OPERATION (GRINDING,
BUFFING, FORGINGS, ETC) MAY RESULT IN POTENTIAL FOR EXPOS TO
AIRBORNE METAL PARTICLATES/FUME. CHRONIC EXPOS TO CU, ZN, PB & MN
MAY CAUSE METAL FUME FEVER. SYMPT INCLUDE FEVER, FATIGUE, DRYNESS
OF THROAT, HEAD & BODY ACHE & CHILLS. OVEREXPOS TO CU & PB MAY
RESULT IN SKIN (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:INGEST OF SIGNIFICANT AMOUNTS OF COPPER ALLOYS ARE
UNLIKELY. SEEK MD HELP IF LARGE QUANTITIES OF PRODUCT ARE INGESTED.
INHAL:REMOVE FROM EXPOSURE OF DUST OR FUME IF PRESENT. SEEK MD HELP
IF REQ UIRED. SKIN:WASH THOROUGHLY WITH SOAP AND WATER. EYE:FLUSH
WITH WATER FOR AT LEAST 15 MINUTES. SEEK MD HELP IF REQUIRED.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . NEVER USE
WATER AS AN EXTINGUISHING AGENT AROUND MOLTEN METAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERE ARE NO FIRE OR EXPLOSION HAZARDS
WITH THESE ALLOYS. WATER WILL REACT VIOLENTLY WITH ANY MOLTEN
METALS.
================== Accidental Release Measures ==================
Spill Release Procedures:PRODUCT IS A NON HAZARDOUS SOLID. NO SPECIAL
PRECAUTIONS ARE REQUIRED FOR SPILLS OF BULK MATERIAL. SCRAP METAL
CAN BE RECLAIMED FOR REUSE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WET MATL SHOULD NEVER BE CHARGED INTO
A MOLTEN BATH. TYPICALLY NO SPECIAL PROT REQD BEYOND THAT REQD FOR
PROCESS OPERATION BEING USED.
BUFFING, ETC, OR ANY OTHER PROCESS THAT GENERATES DUST, FUMES,
CHIPS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE DUST OR FUME LEVELS ARE GREATER THAN THOSE
SPECIFIED IN INGREDIENT SECTION, NIOSH/MSHA APPROVED RESPIRATORY
PROTECTION SHOULD BE USED.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE, ESPECIALLY
BEFORE EATING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:STRIPS, COILS, WIRE, TUBE, INGOTS, CAKE,
CATHODE & SCRAP. EFTS OF OVEREXPOS:& HAIR DISCOLORATION. CHRONIC
EXPOS MAY AFFECT CNS LEADING TO EMOTIONAL DISTURBANCES, GAIT &
BALANC E DIFFICULTIES & PARALYSIS. NICKEL & LEAD HAVE BEEN
IDENTIFIED AS POTENTIAL CANCER CAUSING AGENTS. PROD WILL NOT(ING
12)
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>1500F,>816
Spec Gravity:7.5-9
Solubility in Water:INSOLUBLE
Appearance and Odor:SILVER/YELLOW TO RED SOLID AT ROOM TEMPERATURE AND
EXHIBITS NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MATERIAL MAY REACT WITH ACIDS, BASES OR OXIDIZERS.
Stability Condition to Avoid:ALLOY IS NON HAZARDOUS AT ROOM
TEMPERATURE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW LOCAL, STATE AND FEDERAL REGULATIONS
REGARDING DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:034015 ALCOHOL-ETHANOL
CAGE:81355
CAGE:81355
CAGE:5W146
CAGE:9V533
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 95%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9293
Ingred Name:ALIPHATIC PETROLEUM DISTILLATES
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:100 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE IRRITATION OF EYES,
AND MUCOUS MEMBRANES. MAY CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION
IF INHALED OR INGESTED. CHRONIC: MAY CAUSE SKIN IRRITATION OR
DERMATITIS. MAY CAUSE LIVER DAMAGE.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALATION/INGESTION: DROWSINESS, DIZZINESS,
HEADACHE, GIDDINESS, NAUSEA, VOMITING. EYES: REDNESS, TEARING,
BLURRED VISION. SKIN: REDNESS, RASH, DRY SKIN.
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN, AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT. FURTHER IMPAIRMENT OF LIVER FUNCTION MAY OCCUR IF
PREEXISTING LIVER DISORDERS EXIST.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE MOUTH-TO-MOUTH
RESUSCITATION IF NOT BREATHING. GET MEDICAL ATTENTION IMMEDIATELY.
EYE: IMMEDIATELY FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE
HOLDING EYELID. G ET MEDICAL ATTENTION IMMEDIATELY. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING. INGESTION: DO NOT
INDUCE VOMITING. NOTHING BY MOUTH IF UNCONSCIOUS. GET MEDICAL
ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:55.0F,12.8C
Lower Limits:3.3%
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FULL FIRE FIGHTING PROTECTIVE EQUIPMENT
AND A FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:NOTIFY SAFETY PERSONNEL OF SPILL/LEAK. PROVIDE
MAXIMUM EXPLOSION-PROOF VENTILATION. ELIMINATE ALL SOURCES OF
IGNITION. WEAR PROTECTIVE EQUIPMENT. CONSIDER WATER DILUTION.
ABSORB WITH INERT MATERIAL.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT CONTAINERS FROM PHYSICAL
DAMAGE. STORAGE AND USE CONDITIONS MUST BE SUITABLE FOR AN OSHA
CLASS IB FLAMMABLE LIQUID.
Other Precautions:MAKE FREQUENT CAREFUL LEAKAGE INSPECTIONS. ISOLATE
FROM OXIDEZERS, CHEMICALS CAPABLE OF SPONTANEOUS HEATING, MATERIALS
REACTING WITH AIR OR MOISTURE TO LIBERATE HEAT, IGNITION SOURCES
AND EXPLOSIVES. KEEP OUT OF DIRECT SUN & AWAY FROM HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED RESPIRATORS.
RESPIRATORS SHOULD BE SELECTED BASED ON THE FORM AND CONCENTRATION
OF CONTAMINANT IN AIR & INACCORDANCE WITH OSHA (29 CFR 1910.134).
Ventilation:USE BOTH GENERAL AND LOCAL NONSPARKING, EXPLOSION-PROOF
EXHAUST VENTILATION TO MAINTAIN AIRBORNE LEVELS BELOW TLV/PEL.
Other Protective Equipment:WEAR RUBBER BOOTS, APRONS, AND OTHER
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT SUITABLE TO THE WORK
SITUATION.
Work Hygienic Practices:PRACTICE GOOD PERSONAL HYGIENE. KEEP MATERIAL
OFF CLOTHES AND EQUIPMENT. DO NOT SMOKE ANYWHERE NEAR WORK AREA.
Supplemental Safety and Health
NEVER USE WELDING OR CUTTING TORCH ON OR NEAR DRUM (EVEN EMPTY) BECAUSE
PRODUCT (EVEN JUST RESIDUE) CAN IGNITE EXPLOSIVELY.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:>158F,>70C
Melt/Freeze Pt:M.P/F.P Text:-173F,-114C
Vapor Pres:45 MM HG
Vapor Density:>1 (AIR=1)
Spec Gravity:0.79 (WATER=1)
Evaporation Rate & Reference:6.8 (ETHYL ETHER=1)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS, MOBILE LIQUID
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION. DO NOT USE ALUMINUM CONTAINERS FOR STORAGE AT
TEMPERATURES > 120F.
Hazardous Decomposition Products:CARBON MONOXIDE CAN FORM ON INCOMPLETE
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL SHOULD BE RECLAIMED, RECYCLED OR
INCINERATED IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RPN-225
Resp. Party Other MSDS Num.:BE004004, REVISION: B
CAGE:0KRW1
Contract Num:SP0450-01-M-ZA39
CAGE:0KRW1
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:ACUTE: SKIN AND EYE IRRITATION.
CHRONIC: NONE KNOWN.
Explanation of Carcinogenicity:CARCINOGEN OR SUSPECT CARCINOGEN: NONE.
Effects of Overexposure:ACUTE: SKIN AND EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYE: IN CASE OF CONTACT WITH EYES, FLUSH WITH WATER FOR 20-30
MINUTES. CONSULT A PHYSICIAN IMMEDIATELY. SKIN: FLUSH AFFECTED AREA
WITH WATER FOR 20-30 MINUTES. INGESTION: IF LARGE QUANTITIES ARE
SWALL OWED, DRINK LUKEWARM WATER (NEVER GIVE ANYTHING TO AN
UNCONSCIOUS PERSON). DO NOT INDUCE VOMITING. SEEK MEDICAL ATTENTION
IMMEDIATELY. INHALATION: IF OVERCOME BY EXPOSURE, REMOVE VICTIM TO
FRESH AIR.GIVE OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED. SEEK
MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:FOAM, WATER FOG, CO2.
Fire Fighting Procedures:NONE KNOWN.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS CAN BE WIPED UP. LARGE SPILLS
SHOULD BE CONTAINED IN A CENTRAL AREA AND ABSORBED WITH SAND OR
OTHER SUITABLE ABSORBENT FOR DISPOSAL. CONSULT LOCAL CODES FOR
DISPOSAL. USE CAUTION WHEN HAN DLING.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS
AWAY FROM FLAME AND STRONG OXIDIZING AGENT. KEEP FROM FREEZING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT EXPECTED TO BE NEEDED UNDER NORMAL
CONDITIONS OF USE.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:ALWAYS WEAR PROTECTIVE CLOTHING. EYE BATH
AND SAFETY SHOWER.
Supplemental Safety and Health
NOTE TO PHYSICIAN: TOXICOLOGY STUDIES HAVE SHOWN SIMILAR MATERIAL TO BE
OF VERY LOW ACUTE TOXICITY. THERE IS NO SPECIFIC ANTIDOTE.
TREATMENT OF OVEREXPOSURE SHOULD BE DIRECTED AT THE CONTROL OF
SYMPTO MS AND THE CLINICAL CONDITION OF THE PATIENT.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:>100.C, 212.F
Vapor Pres:<1
Vapor Density:>1.0
Spec Gravity:1.17
pH:= 7-9
Evaporation Rate & Reference:SLOWER
Solubility in Water:COMPLETE
Appearance and Odor:AMBER LIQUID WITH NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT MIX WITH ACIDS, AND/OR STRONG OXIDIZERS. THIS PRODUCT CONTAINS
NITRITE SALTS - DO NOT MIX WITH AMINES OR SUBSTANCES CONTAINING
AMINES.
Hazardous Decomposition Products:WHEN EXPOSED TO FIRE, PRODUCES NORMAL
PRODUCTS OF COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:14025-2 TO 14029-2 J-WAX 100
Preparer's Name:TERRY A MEYERS
CAGE:0U826
CAGE:0U826
CAGE:32204
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM METASILICATE; SODIUM SILICATE; WATER GLASS; DISODIUM
SALT SILIC ACID
CAS:6834-92-0
RTECS #:VV9275000
Fraction by Wt: <1%
Ingred Name:TRISODIUM NITRILOTRIACETATE; NITILOTRIACETIC ACID TRISODIUM
(ANIMAL CARCINOGEN BY IARC-GROUP 2B) *95-1*
CAS:5064-31-3
RTECS #:MB8400000
Fraction by Wt: 1-3%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 85-95%
Ingred Name:QUARTERNARY AMMONIUM COMPOUNDS,
ETHYLBIS(HYDROXYETHYL)TALLOWALKYL, ETHOXYLATED, ET SULFATES
CAS:68071-95-4
Fraction by Wt: 1-3%
Ingred Name:C9-C11 ALCOHOL ETHOXYLATES, NEODOL 91-8 *95-1*
CAS:68439-46-3
Fraction by Wt: <1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: DIRECT CONTACT CAN CAUSE
IRRITATION. SKIN: PROLONGED/REPEATED CONTACT MAY CAUSE IRRITATION.
INGESTION: MAY CAUSE CORROSIVE DAMAGE TO MOUTH, THROAT/STOMACH. NTA
HAS BEEN SHOWN TO INDUCE TUMORS INURINARY TRACTS OF RATS & MICE.
INHALATION: PRODUCT SPRAY MIST/FOG/VAPOR MAY CAUSE IRRITATION TO
NOSE/THROAT & LUNGS.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15-20 MINS. SKIN: WASH W/PLENTY OF
WATER. INGESTION: DRINK LARGE AMOUNTS OF WATER/MILK. IHALATION: IF
MIST, FOG/VAPORS CAUSES DISCOMFORT, REMOVE TO FRESH AIR &
VENTILATE. OBTAI N MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:NORMAL FIRE FIGHTING PROCEDURES MAY BE USED.
COOL & USE CAUTION WHEN APPROACHING/HANDLING FIRE EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CONTAINER MAY BURST IN HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/OIL-DRI/SIMILAR INERT MATERIAL.
SWEEP/SCRAPE UP & CONTAINERIZE. RINSE AFFECTED AREA THOROUGHLY
W/WATER. WEAR/USE APPROPRIATE PROTECTIVE EQUIPMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE W/ADEQUATE
VENTILATION. PRODUCT RESIDUE MAY REMAIN ON/IN EMPTY CONTAINERS.
KEEP FROM FREEZING.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT OF
UNDILUTED PRODUCT W/EYES, SKIN/CLOTHING. ALL PROCAUTIONS FOR
HANDLING THE PRODUCT MUST BE USED IN HANDLING THE EMPTY CONTAINER &
RESIDUE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENTS UNDER NORMAL USE
CONDITIONS.
Ventilation:NO SPECIAL REQUIREMENTS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING/EQUIPMENT
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH: 12.8-13. WASTE DISPOSAL CONT'D: WASTE FROM NORMAL PRODUCT USE MAY
BE SEWERED TO A PUBLIC OWNED TREATMENT WORKS IAW/FEDERAL, STATE &
LOCAL REGULATIONS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>200F
Spec Gravity:1.02
pH:(SUPP)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR AMBER LIQUID W/MILD DETERGENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, MURIATIC ACID.
Stability Condition to Avoid:FREEZING.
Hazardous Decomposition Products:NORMAL PRODUCTS OF COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNDILUTED PRODUCT: DISPENSE UNDER THE RCRA AS A
CORROSIVE WASTE. DISPOSE OF REGULATED QUANTITIES SHOULD BE BY
NEUTRALIZATION AT A PERMITTED FACILITY. (SEE SUPP)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SYNCHRON CX SYSTEMS ELECTROLYTE BUFFER, 443325
CAGE:05721
CAGE:05721
============= Composition/Information on Ingredients =============
Ingred Name:1,3-PROPANEDIOL, 2-AMINO-2-(HYDROXYMETHYL)-; (TRIS-(HYDROXY
METHYL AMINO METHANE))
CAS:77-86-1
RTECS #:TY2900000
Fraction by Wt: 18%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHOSPHORIC ACID (SARA 313) (CERCLA)
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: 5%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/3 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:CORROSIVE TO EYES. CHRONIC:NONE
LISTED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH AFFECTED AREA WITH WATER FOR @ LEAST 15 MINUTES.
INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE O*2/ARTF RESP) . SKIN:FLUSH W/COPIOUS AMOUNTS OF
WATER. CALL MD .
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Fire Fighting Procedures:NOT APPLICABLE. USE NIOSH/MSHA APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON INERT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:18 @ 20C
Vapor Density:0.6
Spec Gravity:1 (H*2O=1)
Evaporation Rate & Reference:1 (H*2O=1)
Solubility in Water:AQUEOUS SOLUTION
Appearance and Odor:CLEAR LIGHT STRAW COLORED SOLUTION, NO SIGNIFICANT
ODOR.
Percent Volatiles by Volume:>70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON, PHOSPHORUS,
NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS MATERIAL MAY BE A HAZARDOUS WASTE AND
SHOULD BE MANAGED IN ACCORDANCE WITH APPROPRIATE FEDERAL, STATE,
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CEE-BEE A-235
Preparer's Name:W. L. BECKTEL
CAGE:71322
CAGE:71322
============= Composition/Information on Ingredients =============
Ingred Name:DICHLOROMETHANE (METHYLENE CHLORIDE) (SUSPECTED HUMAN
CARCINOGEN BY ACGIH, NTP)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 50-75%
OSHA PEL:500 PPM
ACGIH TLV:174 MG/CUM (A2)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PHENOL, CARBOLIC ACID SOLUTION; HYDROXYBENZENE
CAS:108-95-2
RTECS #:SJ3325000
Fraction by Wt: 10-30%
Other REC Limits:5 MG/CUM
OSHA PEL:19 MG/CUM
ACGIH TLV:19 MG/CUM (SKIN)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM CHROMATE
CAS:7775-11-3
RTECS #:GB2955000
Fraction by Wt: <1.5%
OSHA PEL:100 MG/CUM
ACGIH TLV:50 MG/CUM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CORROSIVE. SKIN: CORROSIVE &
ABSORPTION. INHALATION: DIZZINESS, NAUSEA, LIVER, KIDNEY, & BLOOD
DAMAGE.
Explanation of Carcinogenicity:METHYLENE CHLORIDE IS A SUSPECTED HUMAN
CARCINOGEN BY ACGIH.
Effects of Overexposure:EYES: CORROSIVE. SKIN: CORROSIVE & ABSORPTION.
INHALATION: DIZZINESS, NAUSEA, LIVER, KIDNEY, & BLOOD DAMAGE.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/WATER FOR AT LEAST 15 MINS. INHALATION:
REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/ABSORBENT MATERIAL SUCH AS
VERMICULITE. PLACE IN SUITABLE, CLOSED CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINER IN COOL
(32-50F), DRY WELL-VENTILATED AREA. OPEN CONTAINERS SLOWLY &
W/CAUTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED ORGANIC CARTRIDGE
RESPIRATOR.
Ventilation:SUFFICIENT TO KEEP <TLV.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:103F
Vapor Pres:1
Vapor Density:2
Spec Gravity:1.220
pH:10-11
Evaporation Rate & Reference:(BU AC = 1): <1
Solubility in Water:INSOLUBLE
Appearance and Odor:TWO-PHASE LIQUID W/PHENOLIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:OPEN FLAME
Hazardous Decomposition Products:PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:RECLAIM SOLVENTS BY DISTILLATION OR BURN IN AN
APPROVED INCINERATOR OR SEND TO EPA APPROVED WASTE DISPOSAL
FACILITY IN ACCORDANCE W/FEDERAL, STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ZL-60C WATER WASHABLE PENETRANT (PRE 11/89)
Preparer's Name:BRUCE C. GRAHAM, CH. CHEM
CAGE:37676
CAGE:37676
============= Composition/Information on Ingredients =============
Ingred Name:DISTILLATES,(PETROLEUM)HYDROTREATED MIDDLE
CAS:64742-46-7
RTECS #:JN9379645
Fraction by Wt: 40.0%
Ingred Name:KEROSENE
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 10.0%
ACGIH TLV:100 MG/CUM
Ingred Name:PER MFR MSDS, "CONTAINS NO OTHER INGREDIENT SUSPECTED OF
BEING HAZARDOUS ACCORDING TO 29CFR1910.1200 OSHA HAZCOMM RULE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATES EYES. IRRITATES EYES BY
DISSOLVING SKIN OILS. MAY CAUSE STOMACH UPSET IF INGESTED .
Explanation of Carcinogenicity:PER MFR, CONTAINS NO KNOWN OR SUSPECTED
CARCINOGENS LISTED WITH OSHA, THE IARC, OR NTP.
Effects of Overexposure:INHALATION:CAUSES DIZZINESS,DROWSINESS,NAUSEA;
SKIN:LIQUID IRRITATES BY DISSOLVING SKIN OIL; EYES:VAPORS/LIQUID
CAUSES IRRITATION; INGESTION: CAUSES GASTRIC UPSET.
Medical Cond Aggravated by Exposure:NOT KNOWN
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR.IF BREATHING IS DIFFICULT,GIVE
OXYGEN; SKIN:REMOVE CONTAMINATED CLOTHES.WASH OFF WITH FLOWING
WATER.USE SOOTHING LOTION.IF IRRITATION PERSISTS,GET MEDICAL ATTN;
EYES:IMM EDIATELY RINSE/FLUSH WITH COPIOUS AMOUNT OF RUNNING
WATER,AND GET MEDICAL ATTENTION; INGESTION:DO NOT INDUCE VOMITING.
GET MEDICAL ASSISTANCE IF INGESTED.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F/>93C
Lower Limits:6.0
Upper Limits:1.0
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.DO NOT
SPRAY WATER ON BURNING PRODUCT.
Unusual Fire/Explosion Hazard:WHEN INVOLVE IN COMBUSTION,MAY EMIT TOXIC
GASES AT OR ABOVE DECOMPOSITION TEMPERATURE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.SMALL
SPILL:WIPE-UP/MOP UP BUT DO NOT BREATHE VAPORS. PLACE RAGS IN
CLOSED DRUMS; LARGE SPILL:WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA
FAR AHEAD.ABSORB LIQUID WITH COMMERCIAL ABSORBENT.TRANSFER WASTE
MATERIAL TO SALVAGE TANK.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA.AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS.KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS.DO NOT SMOKE WHILE USING.DO NOT
HEAT ABOVE 130F(54C).AVOID FREQUENT OR PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A RESPIRATOR WITH ABSORBENT CARTRIDGE IN
POORLY VENTILATED AREAS. IN CONFINED AND UNVENTILATED SPACES, WEAR
FULL MASK WITH AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW TLV LIMITS.
Work Hygienic Practices:WASH HANDS WITH SOAP/WATER AFTER HANDLING/USE.
Supplemental Safety and Health
ITEM IS ONE PART;NSN ESTABLISHED IN 1987 WAS FOR TYPE I,METHOD A,LEVEL
2 MATERIALS;THIS ENTRY DESCRIBES OLD FORMULA OF ZL-60C PENETRANT
WHICH IS TYPE I,METHOD A,LEVEL 2 ITEM AS SPECIFIED BY QPL-25135- 15
FOR MIL-I25135,REV "E"; SEE PNI 'D' FOR NEW ITEM AND OTHER PNI FOR
MORE ITEMS OF MAGNAFLUX FOR SAME TYPE,METHOD & LVL
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:410F/210C
Vapor Pres:0.5 @100F
Vapor Density:>1.0
Spec Gravity:0.88
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREEN OILY LIQUID,PETROLEUM HYDROCARBON
Percent Volatiles by Volume:5.0%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT,HIGH TEMPERATURES.
Hazardous Decomposition Products:EMITS OXIDES OF CARBON AND NITROGEN
WHEN BURNING.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF AS EPA HAZARDOUS WASTE
#D001 (IGNITABLE WASTE),I/A/W ALL APPLICABLE FEDERAL,STATE,LOCAL
REGULATIONS;IF LOCAL REGS PROHIBIT DUMPING RINSINGS DOWN THE
SEWER,PURIFY RINSINGS WITHMAGNAFLUX WASTE WATER TREATMENT SYSTM.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BLUE GOLD INDUSTRIAL CLEANER (NON-FOAMING)
CAGE:59972
CAGE:59972
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL,2-(2-BUTOXYETHOXY); (DIETHYLENE GLYCOL MONOBUTYL
ETHER)
CAS:112-34-5
RTECS #:KJ9100000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN AND EYE IRRITATIONS.
INGESTION MAY BE HARMFUL.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:UNDETERMINED.
======================= First Aid Measures =======================
First Aid:INGEST: ALKALINE MATERIAL. DO NOT INDUCE VOMITING. ADMINISTER
MILDLY ACIDIC SUBSTANCE, SUCH AS EGG WHITE. INHAL: EXPOSED TO FRESH
AIR. SKIN: WASH OFF. EYE: FLUSH WITH WATER FOR AT LEAST 15 MINUTES.
SE E PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE WITH WATER AND CLEAN UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE. MATERIAL CAN BE STORED OUTSIDE.
Other Precautions:NONE. MATERIAL IS FREEZABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST:ACCEPTABLE.
Other Protective Equipment:NONE NEEDED.
Work Hygienic Practices:NORMAL SAFETY PROCEDURES.
Supplemental Safety and Health
PH: 11.1@1% SOLUTION, 13 CONCENTRATE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:208F,98C
Vapor Pres:23.76@25C
Spec Gravity:1.07(H*2O=1)
pH:SUPDAT
Solubility in Water:COMPLETE
Appearance and Odor:BLUE LIQUID/SLIGHT PEPPERMINT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:REMOVE PARTICULATE MATERIALS AND OILS. DISPOSE
IN ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS. PH
ADJUSTMENT MAY BE NECESSARY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CNS WOOD PRESERVATIVE,GREEN,73-0002
Preparer's Name:ROBERT W. COOK
CAGE:0NXH7
CAGE:0NXH7
CAGE:4S446
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC/MINERAL
SPIRITS
CAS:64742-88-7
Fraction by Wt: 60.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:TRADE SECRET COMPONENT/CONT'L NAPHTHENATE AND 8% COPPER
Fraction by Wt: 30.3%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ALIPHATIC PETROLEUM SOLVENT/KEROSENE
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 9.2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:VOLATILE ORGANIC CONTENT (LESS WATER) AS LISTED ON MSDS:
4.94 LBS/GAL.
RTECS #:9999999VC
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, CNS,
RESPIRATORY & GI TRACTS. ACUTE- MAY CAUSE EYE AND SKIN IRRITATION.
HIGH VAPOR CONCENTRATIONS MAY PRODUCE RESPIRATORY IRRITATION, CNS
EFFECTS. INGESTION MAY CAUSE VOMITING . ASPIRATION HAZARD. CHRONIC-
UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA,
TEARING, BLURRED VISION
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED CNS OR RESPIRATORY FUNCTION MAY
BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT IN DUCE VOMITING. IF CONSCIOUS, RINSE MOUTH WITH WATER. SEEK
IMMEDIATE MEDICAL ATTENTION. IF SPONTANEOUS VOMITING OCCURS, KEEP
HEAD BELOW HIPS.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:104F,40C
Extinguishing Media:USE FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T USE
DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. PICK UP SPILL WITH NON-FLAMMABLE
ABSORBENT SUCH AS SAND OR VERMICULITE. PREVENT LIQUID FROM ENTERING
SEWERS OR WATERWAYS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA, AWAY
FROM SUN, IGNITION SOURCES & STRONG OXIDIZING AGENTS. KEEP
CONTAINER TIGHTLY CLOSED.
Other Precautions:DO NOT REUSE PRODUCT CONTAINER FOR ANY PURPOSE. KEEP
OUT OF REACH OF CHILDREN. DO NOT BREAHTE VAPOR/MIST. AVOID EYE AND
SKIN CONTACT. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, WEAR A
NIOSH-APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:USE EXPLOSION-PROOF VENTILATION EQUIPMENT TO CONTROL VAPOR
CONCENTRATIONS.
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:300F - 365F
Vapor Density:>1
Spec Gravity:0.851
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:GREEN LIQUID - CHARACTERISTIC ODOR
Percent Volatiles by Volume:76.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT (TEMPERATURES ABOVE 120F), FLAMES,
SPARKS, HOT SURFACES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN AN APPROVED INCINERATOR OR
CONTRACT WITH LICENSED CHEMICAL WASTE DISPOSAL SERVICE. DISCHARGE,
TREATMENT OR DISPOSAL IS SUBJECT TO FEDERAL, STATE OR LOCAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SCOTCHCAST BRAND RESIN#208,PART B.
Kit Part:Y
CAGE:76381
CAGE:76381
============= Composition/Information on Ingredients =============
Ingred Name:NONYL PHENOL
CAS:25154-52-3
RTECS #:SM5600000
Fraction by Wt: 3%
Ingred Name:FATTY ACID AMIDE
Fraction by Wt: 75%
Ingred Name:AROMATIC HYDROCARBON RESIN
Fraction by Wt: 18%
Ingred Name:DIETHYLENE TRIAMINE
CAS:111-40-0
RTECS #:IE1225000
Fraction by Wt: 2%
OSHA PEL:1 PPM
ACGIH TLV:S, 1 PPM; 9192
===================== Hazards Identification =====================
Effects of Overexposure:IRRITATING TO EYES,RESPIRATORY,INGESTION
SYSTEMS. MAY BE HARMFUL IF ABSORBED THRU SKIN.
======================= First Aid Measures =======================
First Aid:USE STANDARD FIRST AIR PROCEDURES. CALL EMERGENCY MEDICAL
CARE.
===================== Fire Fighting Measures =====================
Flash Point:>390F/199C(CC)
Extinguishing Media:CO*2, FOAM, DRY CHEM.
Fire Fighting Procedures:WEAR SELF-CNTD BRTHG APP; EXTINGUISH WHEN FLOW
STOPPED.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATL AS NEEDED AND SWEEP UP.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING IN VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR SCBA,IN FIRE, OTHERWISE NIOSH APPRVD RESPIR
Ventilation:MECHANICAL (GENERAL/LOCAL EXHAUST)
Other Protective Equipment:PROTECTIVE CLOTHING.
Supplemental Safety and Health
MSDS DATED 10-23-85.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.07
Solubility in Water:NIL
Appearance and Odor:BROWN VISCOUS LIQ,AMINE ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO,CO*2,OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION OR LANDFILL ACCORDING TO
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HELIUM
CAGE:LO751
CAGE:2W147
CAGE:LO751
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:EFFECTS OF EXPOSURE TO HIGH CONCENTRATIONS SO
AS TO DISPLACE THE OXYGEN IN THE AIR NECESSARY FOR LIFE ARE
HEADACHE, DIZZINESS, LABORED BREATHING AND EVENTUAL
UNCONSCIOUSNESS. BREATHING MIXTURES OF H ELIUM WITH ADEQUATE OXYGEN
TO SUPPORTLIFE MODIFIES THE VOICE SOUND SO THAT IT IS HIGHER
"PITCHED".
======================= First Aid Measures =======================
First Aid:PROMPT MEDICAL ATTENTION IS MANDATORY IN ALL CASES OF
OVEREXPOSURE TO HELIUM. RESCUE PERSONNEL S/B EQUIPPED
W/SELF-CONTAINED BREATHING APPARATUS. INHALATION: CONSCIOUS PERSONS
S/B ASSISTED TO AN UNC ONTAMINATED AREA AND INHALE FRESH AIR.QUICK
REMOVAL FROM CONTAMINATED AREA IS MOST IMPORTANT. UNCONSCIOUS
PERSONS S/B MOVED TO UNCONTAMINATED AREA/VENT CPR/SUPP OXY FURTHER
TREATMENT S/B SYMPTOMATIC
===================== Fire Fighting Measures =====================
Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NON-FLAMMABLE, INERT GAS
Fire Fighting Procedures:NA
Unusual Fire/Explosion Hazard:NA
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL PERSONNEL FROM AFFECTED AREAS.
USE APPROPRIATE PROTECTIVE EQUIPMENT. IF LEAK IS IN CONTAINER
OR CONTAINER VALVE, CONTACT YOUR CLOSES SUPPLIER LOCATION OR CALL
======================Handling and Storage ======================
Handling and Storage Precautions:PROT CYL FM DAM. STORE IN
COOL/DRY/WELL VENT AREA.DO NOT STORE > 130F. CYL SHOULD BE STORED
UPRIGHT/SECURE. FULL/EMPTY CYL S/B SEGRE. MONITOR CYL USE.
Other Precautions:COMPRESSED GAS CYLINDERS SHOULD NOT BE REFILLED
EXCEPT BY QUALIFIED PRODUCERS OFCOMPRESSED GASES. SHIPMENT OF A
COMPRESSED GAS CYLINDER WHICH HAS NOT BEEN FILLED BY THE OWNER
OF W/HIS (WRITTEN) C ONSENT IS A VIOLATION OF FED LAW (49CFR)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:POSITIVE PRESSURE AIR LINE WITH MASK OR
SELF-CONTAINED BREATHING APPARATUS SHOULD BE AVAILABLE FOR
EMERGENCY USE.
Ventilation:TO PREVENT ACCUMULATION OF HIGH CONCENTRATIONS SO AS TO RE-
DUCE THE OXYGEN LEVEL IN THE AIR TO LESS THAN 18 MOLAR %.
Other Protective Equipment:SAFETY SHOES
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-452.1F
Vapor Density:.0103LBFT3
Spec Gravity:.138 70F AIR=1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS, ODORLESS GAS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NA
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ATTEMPT TO DISPOSE OF WASTE/UNUSED
QUANTI- TIES. RETURN IN SHIP CONTAINER PROPERLY LABELED W/ANY VALVE
OUTLET PLUGS/CAPS SECURED/VALVE PROT CAPIN PLACE TO YR SUPPLIER.
FOR EMER DISPOSAL ASSIST. CONTACT YR CLOSED SUPP LOCAL/CALL EMER
TELE LISTED
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TT-L-32A, TYPE 2 (17875 WHITE), PC 1571W11
Preparer's Name:C A HOPE
CAGE:00297
CAGE:00297
============= Composition/Information on Ingredients =============
Ingred Name:DI(2-ETHYL HEXYL) PHTHALATE (SARA 313) (EXPOSURE LIMITS ARE
FOR DI-SEC-OCTYL PHTHALATE)
CAS:117-81-7
RTECS #:TI0350000
Fraction by Wt: 1-5%
Other REC Limits:NIOSH USE LOWEST POS
OSHA PEL:5 MG/M3;10MG/M3 STEL
ACGIH TLV:5 MG/M3;10MG/M3 STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ISOBUTYL ACETATE
CAS:110-11-9
RTECS #:AI4025000
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150PPM TWA;700 MG/M3
ACGIH TLV:150 PPM;187 PPM STEL
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5-10%
Other REC Limits:NIOSH100PPM/19HR TWA
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:N-BUTYL ALCOHOL (SARA 313) (SKIN)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:N-BUTYL ACETATE
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/200 PPM STEL
ACGIH TLV:150 PPM/200 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ISOBUTYL KETONE (SARA 313)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (NIOSH EXPOSURE LIMIT 800 PPM; 15 MIN
CEILING SEE RECOMM EXPOS LIMIT BELOW FOR MORE INFO )
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 1-5%
Other REC Limits:NIOSH400PPM/10HR TWA
OSHA PEL:400 PPM/500 PPM STEL
ACGIH TLV:400 PPM/500 PPM STEL
Ingred Name:VM&P NAPHTHA
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:300 PPM/400 PPM STEL
ACGIH TLV:300 PPM /1350 MG/M3
Ingred Name:ISOBUTYL ALCOHOL
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10-15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:METHYL ETHYL KETONE
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/300 PPM STEL
ACGIH TLV:200 PPM/300 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYLENE GLYCOL MONOBUTYL ETHER (SKIN)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE: IRRIT, REVERSBL CORNEAL INJURY.
SKIN: PROLONG/REPEAT-DRYING, IRRIT, DERMATITIS. ABSORP: SYSTEMIC
EFFECTS. INHAL: NAUSEA, DIZZY, HEADACHE, CENTRAL NERV SYS DEPRESS,
WEAK, COORDINATION LOSS. REPEAT OVEXPOS LIVER, KIDNEY, BLOOD
INJURY. INGEST: NAUSEA, VOMIT, DIARRHEA. ASPIRATION (LUNG)-CHEM
PNEUMONITIS-CAN BE FATAL.
Explanation of Carcinogenicity:NTP HAS DETERMINED THERE IS SUFFICIENT
EVIDENCE FOR CARCINOGENICITY OF DIOCTYL PHTHALATE IN EXPERIMENTAL
ANIMALS.
Medical Cond Aggravated by Exposure:INDIVIDUALS W/PRE-EXISTING DISEASE
IN OR A HISTORY OF AILMENTS INVOLVING LIVER, KIDNEY, BLOOD, SKIN
CENTRAL NERVOUS SYSTEM ARE AT GREATER THAN NORMAL RISK OF
DEVELOPING ADVERSE EFFECTS WHEN EXPOSED.
======================= First Aid Measures =======================
First Aid:EYE: IMMED FLUSH W/WATER 15 MIN. IMMED SEEK MED AID. SKIN:
WASH W/SOAP & WATER OR WATERLESS HAND CLEANER. IF IRRIT PERSISTS,
SEEK MED AID. INHAL: REMOVE FROM EXPOS. IF BREATHING
STOPPED/DIFFICULT, ADM IN ARTIF RESP/OXYGEN AS INDICATED. SEEKMED
AID. INGEST: DON'T INDUCE VOMITING. GIVE 1 GLASS MILK/1-2 OZ
ACTIVATED CHARCOAL IN WATER. IMMED GET MED AID. NOTHING BY MOUTH TO
UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:25.0F,-3.9C
Extinguishing Media:WATER MAY BE INEFFECTIVE. USE CARBON DIOXIDE, DRY
CHEMICAL SPRAY, ALCOHOL OR UNIVERSAL TYPE FOAMS AS PER MFR'S
RECOMM.
Fire Fighting Procedures:WEAR COMPLETE FIRE SERVICE PROTECTION EQUIP,
INCLUDING FULL FACE MSHA/NIOSH SCBA. USE WATER TO COOL FIRE EXPOSED
CONTAINER/STRUCTURE/PROTECT PERSONNEL.
Unusual Fire/Explosion Hazard:VAPORS FORM FLAMM/EXPLOS MIX W/AIR.
VAPORS HEAVY, TRAVEL (GROUND, PIT, SEWER) TO IGNIT SOURCE-FLASH.
CNTNRS MAY CONTAIN FLAMM/EXPLOS VAPORS. TOXIC/IRRIT GAS *
================== Accidental Release Measures ==================
Spill Release Procedures:STOP IF NO RISK. AVOID BREATH. ELIMINATE IGNIT
SOURCES. VENT AREA. AVOID CONTACT W/HOT LIQ/FUMES. TAKE UP W/CARE
(AVOID HEAT/SPARKS). USE INERT ABSORBENT. 21FEB92EACTS W/OXIDIZING
MAT'LS. REPORT PROD SPILLED (NAT RSPNS CTR 800-424-8802. RPT QT
100LB.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING. AVOID SKIN/EYE/CONTAM
CLOTH CONTACT. HANDLE/USE IN ACCORD W/OSHA 29CFR1910.106/LOCAL
CODES. GRND/BOND DRUMS. NO PRESSURE TO EMPTY.
Other Precautions:STORE IN AREAS/BLDG (OSHA 1910.106), COOL (WELL
SHADED), DRY, VENTED AREA. PROTECT FROM PHYSICAL DAMAGE. KEEP IN
CLSD (WHEN NOT IN USE), LABLED CNTNR. MAINTAIN GOOD HOUSEKEEPING.
NOT FOR USE/STOR IN/A ROUND HOME. KEEP FROM HEAT/OPEN FLAME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED EXCEPT WHEN HEATED/MISTED
(AEROSOLIZED). IF VENTILATION DOESN'T MAINTAIN INHALATION EXPOSURES
BELOW TLV. USE MSHA/NIOSH UNITS (29 CFR 1910.134) & MFRS
"INSTRUCTIONS" & "WARNINGS. USE MSHA/NIOSH UNITS PER
29CFR1910.134.
Ventilation:LOCAL EXHAUST IN ENCLOSED/CONFINED SPACES (OSHA 87-113
"CONFINED SPACES"). PROVIDE SUFF GEN (PATTN/VOL) KEEP BELOW TLV.
Other Protective Equipment:DEPENDING ON WRKNG COND (CONTACT), INDUST
WRK CLOTH, SAFETY FOOTWER, HEAD/NECK COVER, APRONS, JACKETS, PANTS,
COVERALLS.
Work Hygienic Practices:WASH CONTAM CLOTHING BEFORE REUSE. DISCARD
CONTAM FOOTWEAR. OBSERVE GOOD PERSONAL HYGIENE PRACTICES & RECOMM
PROCEDURES.
Supplemental Safety and Health
NOTE TO PHYSICIAN: THERE IS NO SPECIFIC ANTIDOTE FOR EFFECTS FROM
OVEREXPOSURE TO THIS MATERIAL. TREATMENT SHOULD BE DIRECTED AT THE
CONTROL OF SYMPTOMS AND THE CLINICAL CONDITION.
================== Physical/Chemical Properties ==================
HCC:F2
Vapor Density:>1
Spec Gravity:7.5-8.0 LB/GAL
Evaporation Rate & Reference:>1 (BU AC=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE VISCOUS LIQUID WITH TYPICAL SOLVENT ODOR.
Percent Volatiles by Volume:50-70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ALKALIES, ACIDS.
Stability Condition to Avoid:HIGH TEMPERATURES, OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE, FUMES OF CHROMATE AND
LEAD OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT IS AN US EPA DEFINED IGNITABLE
HAZARDOUS WASTE. DISPOSE OF AS AN IGNITABLE HAZARDOUS WASTE IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CODE-ARC 7018 MR ELECTRODES
CAGE:83923
CAGE:83923
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:10 MG/M3(IRON OXIDE)
ACGIH TLV:5 MG/M3 (IRON OXIDE)
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
Ingred Name:CALCIUM FLUORIDE
CAS:7789-75-5
RTECS #:EW1760000
OSHA PEL:2.5 MG/M3 (F)
ACGIH TLV:2.5 MG/M3 (F); 8990
Ingred Name:POTASSIUM TITANATE
CAS:12030-97-6
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SHORT TERM EXPOSURE TO WELDING FUMES,
GASES OR DUST MAY RESULT IN DISCOMFORT SUCH AS DIZZINESS, NAUSEA,
FEVER, DRYNESS AND/OR IRRITATION OF NOSE, THROAT AND EYES. SKIN
SENSITIVITY MAY ALSO BE NOTED. A CUTE EXPOSURE FROM SOME TOXIC
GASES MAYCAUSE PULMONARY EDEMA, ASPHYXIATION AND EXCESSIVE EXPOSURE
CAN BE FATAL.
Effects of Overexposure:EXPOSURE TO WELDING FUMES MAY RESULT IN
DISCOMFORT SUCH AS DIZZINESS, NAUSEA, FEVER, DRYNESS AND/OR
IRRITATION OF NOSE, THROAT AND EYES. SKIN SENSITIVITY MAY ALSO BE
NOTED. WATERY EYES, HEADACHE, BREA THING DIFFICULTY, FREQUENT
COUGHING AND/OR CHEST PAINS MAY OCCURE FROM ACUTE EXPOSURE. TOXIC
GASES CAN BE FATAL.
Medical Cond Aggravated by Exposure:SOME WORKERS MAY BE AFFECTED BY A
PRE-EXISTING CONDITION OR OTHER OCCUPATIONAL ILLNESS BECAUSE OF THE
WIDE VARIATION IN INDIVIDUAL SUSCEPTIBILITIES.
======================= First Aid Measures =======================
First Aid:IN CASE OF ELECTRICAL SHOCK, TURN OFF POWER PRIOR TO REMOVAL
FROM EXPOSURE AREA AND ADMINISTRATION OF FIRST AID. REMOVE FROM
EXPOSURE AREA AND CALL FOR MEDICAL AID. ADMINISTER OXYGEN IF
BREATHING IS D IFFICULT. IF NOT BREATHING, BEGIN ARTIFICIAL
RESPIRATION. IF NO DETECTABLE PULSE, BEGIN EXTERNAL HEART MASSAGE.
EMPLOY FIRST AID TECHNIQUES RECOMMENDED BY THE AMERICAN RED CROSS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NOT APPLICABLE;USE CARBON DIOXIDE, FOAM, DRY
CHEMICAL, OR WATER FOG IN CASE OF SURROUNDING FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NON-FLAMMABLE. WELDING ARC AND SPARKS CAN
IGNITE COMBUSTIBLES AND FLAMMABLE PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUES
AND PLACE IN SUITABLE DOT APPROVED CONTAINERS AND DISPOSE OF IN
FULL COMPLIANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS. AVOID
INHALATION AND SKIN EXPOSU RE.
======================Handling and Storage ======================
CLOTHING WHEN CUTTING, GRINDING OR WELDING. DO NOT EXPOSE SKIN TO
RADIATION WHEN HOT CUTTING OR WELDING.
Other Precautions:PROVIDE PROTECTIVE SCREENS TO SHIELD OTHERS. WHEN
ELECTRODES AND FLUXES ARE CONSUMED, THE FUME AND GAS DECOMPOSITION
PRODUCTS GENERATED ARE DIFFERENT IN FORM FROM THE INGREDIENTS
LISTED. NEW COMPOUNDS NOT IN THE ELECTRODES MAY FORM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE WELD FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN CUTTING, GRINDING OR WELDING IN A CONFINED SPACE OR
WHERE LOCAL EXHAUST OR GENERAL VENTILATION DOES NOT KEEP EXPOSURE
BELOW RECOMMENDED LIMITS. USE ONLY NIOSH APPROVED RESPIRATORS.
Ventilation:USE ENOUGH VENTILATION WHEN CUTTING, GRINDING OR WELDING TO
KEEP THE DUST, FUMES & GASES FROM THE WORKERS BREATHING ZONE
Other Protective Equipment:FLAME RETARDANT CLOTHING WHEN CUTTING,
GRINDING OR WELDING. DO NOT EXPOSE SKIN TO RADIATION WHEN HOT
CUTTING OR WELDING.
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING OR SMOKING.
LAUNDER CONTAMINATIED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
WELDING AND HOT CUTTING FUMES & GASES CANNOT BE CLASSIFIED SIMPLY.
THEIR COMPOSITION AND QUANTITY ARE DEPENDENT ON THE METAL BEING
WELDED, THE PROCEDURES, PROCESSES AND THE TYPE OF WIRE OR
ELECTRODESUSED. OTHER INFLUENCING FACTORS ARE THEPRESENCE OF
CONTAMINANTS. CHLORINATED SOLVENTS MAY DECOMPOSE TO TOXIC GASES.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:INSOLUBLE.
Appearance and Odor:FLUX COATING ON A SOLID METAL CORE WIRE IN CUT
LENGTHS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE NOTED
Stability Condition to Avoid:NONE NOTED
Hazardous Decomposition Products:WELDING AND CUTTING OPERATION MAY
INCLUDE OXIDES OF THE METALS, CHROMATES, FLUORIDES, COMPLEX
METALLICS, AND OZONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL, STATE & LOCAL REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:28F850
CAGE:01002
CAGE:01002
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS PE RSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMATIC ODOR.
================= Stability and Reactivity Data =================
STRONG OXIDIZERS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SA61D GLOSS BLACK EPOXY BAKING ENAMEL
CAGE:34227
CAGE:34227
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-3*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 20-25%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE *96-3*
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 1-5%
Other REC Limits:100 PPM
OSHA PEL:435 MG/CUM
ACGIH TLV:434 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPYLENE GLYCOL METHYL ETHER (1-METHOXY-2-PROPANOL)
PROPYLENE GLYCOL MONO METHYL ETHER *96-3*
CAS:107-98-2
RTECS #:UB7700000
Other REC Limits:100 PPM
ACGIH TLV:100 PPM
Ingred Name:DIACETONE ALCOHOL
CAS:123-42-2
RTECS #:SA9100000
Other REC Limits:50 PPM
OSHA PEL:240 MG/CUM
ACGIH TLV:238 MG/CUM
Ingred Name:COLUMBIA CARBON, CARBON BLACK, LAMPBLACK, BLACK PEARLS
(IARC CARC GROUP 3) - *96-3*
CAS:1333-86-4
RTECS #:FF5800000
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/CUM
ACGIH TLV:3.5 MG/CUM
Ingred Name:BISPHENOL A EPOXY RESIN *96-3*
CAS:25036-25-3
Ingred Name:BASIC LEAD PHOSPHITE *96-3*
CAS:12141-20-7
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATING, CORNEAL INJURY.
SKIN: MODERATELY IRRITATING, MAY CAUSE DAMAGE, ABSORPTION &
DERMATITIS.INHALATION: IRRITATION TO NOSE, THROAT, RESPIRATORY
TRACT & MUCOUS MEMBRANES, CNS DEPRESSION, L EAD POISONING, SEVERE
DAMAGE TO THE BLOOD-FORMING, NERVOUS, URINARY, REPRODUCTIVE SYSTEMS
& DAMAGE TO LUNGS. (SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DEFATTING, DRYNESS, HEADACHE,
DIZZINESS, NAUSEA, INTOXICATION, UNCONSCIOUSNESS, LOSS OF APPETITE,
METALLIC TASTE IN THE MOUTH, ANXIETY, CONSTIPATION, PALLOR,
EXCESSIVE TIREDNESS, WEAKNESS, INSOMNIA, NERVOUS IRRITABILITY,
MUSCLE& JOINT PAIN, FINE TREMORS, NUMBNESS, HYPERACTIVITY, COLIC.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN, EYE,
RESPIRATORY, IMPAIRED CNS FUNCTION DISORDERS. PRE-EXISTING
SKIN/LUNG ALLERGIES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WIPE EXCESS & FLUSH
W/WATER USING SOAP. INHALATION: REMOVE TO FRESH AIR & TREAT
SYMPTOMATICALLY. GIVE OXYGEN/CPR IF NEEDED. INGESTION: DON'T INDUCE
VOMITING. IF VOMITING SPONTANEOUSLY OCCURS, KEEP HEAD BELOW THE
HIPS TO PREVENT ASPIRATION INTO THE LUNGS. WHETHER/NOT TO INDUCE
VOMITING SHOULD BE MADE BY A PHYSICIAN. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:53-57F
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CO2.
Fire Fighting Procedures:EVACUATE AREA. DON'T ENTER CONFINED FIRE SPACE
W/O PROPER PROTECTIVE EQUIPMENT & POSITIVE PRESSURE NIOSH APPROVED
SCBA. COOL CONTAINERS W/LARGE AMOUNTS OF WATER
Unusual Fire/Explosion Hazard:FLAMMABLE. CONTAINERS EXPOSED TO INTENSE
HEAT COULD RESULT IN CONTAINER RUPTURE. VAPORS MAY ACCUMULATE &
TRAVEL TO IGNITION SOURCES DISTANT FROM HANDLING SITE.
================== Accidental Release Measures ==================
Spill Release Procedures:LARGE: EVACUATE AREA. WEAR APPROPRIATE
RESPIRATOR & PROTECTIVE CLOTHING. SHUT OFF SOURCES OF LEAK SAFELY,
DIKE & CONTAIN. IF VAPOR CLOUD FORMS, WATER FOG MAY BE USED TO
SUPPRESS. CONTAIN RUN-OFF. REMO VE W/VACUUM TRUCKS/PUMP TO
STORAGE/SALVAGE VESSELS
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP LIQUID AWAY FROM HEAT, SPARKS,
FLAME & OTHER SOURCES OF IGNITION. KEEP CONTAINERS CLOSED WHEN NOT
IN USE. USE W/ADEQUATE VENTILATION.
Other Precautions:CONTAINERS, EVEN IF EMPTY CAN CONTAIN EXPLOSIVE
VAPORS. DON'T CUT, DRILL, GRIND/WELD NEAR CONTAINERS. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE CONTENTS MAY BE
HARMFUL/FATAL. HOTSURFACES MAY IGNITE W/O SPARKS/FLAME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE EXCEEDS TLV USE A NIOSH APPROVED
RESPIRATOR TO PREVENT OVEREXPOSURE.
Ventilation:REQUIRED
Other Protective Equipment:EYE WASH FOUNTAINS & SAFETY SHOWERS,
SYNTHETIC APRON.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING & SHOES, DON'T
REUSE UNTIL THOROUGHLY DECONTAMINATED.
Supplemental Safety and Health
WASH W/SOAP & WATER BEFORE EATING, DRINKING, SMOKING/USING TOILET
FACILITIES. HLTH HZRD-INGESTION: MAY CAUSE RED BLOOD CELL
HEMOLYSIS, KIDNEY & LIVER DAMAGE. LIQUID ASPIRATED INTO THE LUNGS
DURING ING ESTION/VOMITING MAY RESULT IN SEVERE LUNG DAMAGE. GI
TRACT IRRITATION. SPILLS: SOAK UP RESIDUE W/ABSORBENT & DISPOSE OF.
================== Physical/Chemical Properties ==================
Vapor Density:>1
Evaporation Rate & Reference:(N-BU AC = 1): 0.00
Percent Volatiles by Volume:(SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:HEAT, SPARKS, FLAME, HOT SURFACES &
SOURCES OF IGNTION.
Hazardous Decomposition Products:COMBUSTION: LEAD OXIDE FUMES, CO2, CO
& UNIDENTIFIED ORGANIC COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:5760/5765/5790/DOCUCOLOR 40 YELLOW TONER, 6R60403
CAGE:0E6G9
CAGE:0E6G9
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:POLYESTER
CAS:128781-91-9
Fraction by Wt: >90%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIGMENT YELLOW 17; (YELLOW PIGMENT)
CAS:4531-49-1
Fraction by Wt: 4-8%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <2%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SPILL PROC: MACHINE SHOULD BE USED TO REDUCE STATIC
BUILDUP. RESIDUE CAN BE REMOVED WITH SOAP AND COLD WATER. (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: GARMENTS MAY BE WASHED OR DRY CLEANED, AFTER REMOVAL
OF LOOSE TONER.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: AUTHORITIES IS ADVISED. INCINERATE ONLY IN
A CLOSED CONTAINER.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP: AS IN BULK TONER PROCESSING FACILITIES),
CONTACT XEROX FOR MORE INFORMATION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) >5 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MINIMAL RESPIRATORY TRACT IRRITATION
MAY OCCUR AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY NON-TOXIC DUST.
THE RESULTS OBTAINED FROM A XEROX SPONSORED, CHRONIC TONER
INHALATION STUDY, DEMONSTRATED NO LUN G CHANGE IN RATS FOR THE
LOWEST (1MG/M3) EXPOSURE LEVEL (I.E. THE LEVEL MOST RELEVANT TO
POTENTIAL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: HUMAN EXPOSURE). A VERY SLIGHT DEGREE
OF FIBROSIS WAS NOTED IN ONE-FOURTH OF THE ANIMALS AT THE MIDDLE
(4MG/M3) EXPOSURE LEVEL, WHILE A SLIGHT DEGREE OF FIBROSIS WAS
NOTED IN ALL ANIMALS AT THE HIGHEST (16MG/M3) EXPOSURE LEVEL.
THESE FINDINGS ARE ATTRIBUTED TO "LUNG OVERLOADING" A GENERIC
RESPONSE TO (SUPDAT)
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH SOAP AND WATER. INHALATION: REMOVE FROM EXPOSURE. INGESTION:
DILUTE STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, DRY CHEMICAL, CARBON DIOXIDE OR FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. LIKE MOST
ORGANIC MATERIALS IN POWDER FORM, WHEN DISPERSED IN AIR, IT CAN
FORM EXPLOSIVE MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR VACUUM SPILLED TONER & CAREFULLY
TRANSFER INTO A SEALABLE WASTE CONTAINER. SWEEP SLOWLY TO MINIMIZE
GENERATION OF DUST DURING CLEAN-UP. IF A VACUUM IS USED, THE MOTOR
MUST BE RATED AS DUST TIGHT. A CONDUCTIVE HOSE BONDED TO THE(ING
4)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:AVOID PROLONGED INHALATION OF EXCESSIVE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED. USE NIOSH
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . FOR
USE OTHER THAN NORMAL CUSTOMER-OPERATING PROCEDURES (SUCH (ING 7)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: EXCESSIVE AMOUNTS OF ANY DUST RETAINED IN THE LUNGS
FOR A PROLONGED PERIOD. THIS STUDY WAS CONDUCTED USING SPECIAL TEST
TONER TO COMPLY W/EPA TESTING PROTOCOL. TEST TONER WAS TEN TIME S
MORE RESPIRABLE THAN COMMERCIALLY AVAILABLE XEROX TONER & WOULD NOT
BE FUNCTIONALLY SUITABLE FOR XEROX EQUIPMENT.
================== Physical/Chemical Properties ==================
Appearance and Odor:YELLOW POWDER; FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION MAY BE TOXIC.
AVOID BREATHING SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN DISPOSED, THIS MATERIAL IS NOT A HAZARDOUS
WASTE ACCORDING TO FEDERAL REGULATION 40 CFR 261. HOWEVER, STATE
AND LOCAL REQUIREMENTS MAY BE MORE RESTRICTIVE. THEREFORE,
CONSULTATION WITH THE APPROP RIATE STATE AND LOCAL WASTE DISPOSAL
(ING 6)
| 1 | gloves_mandatory |
=======================================================
Product ID: BL-217; ANTIQUE IVORY BRUSHING LACQUER
Cage: 35178
=======================================================
Contractor Summary
=======================================================
Cage: 1055X
Cage: 35178
=======================================================
Ingredients
=======================================================
Cas: 108-88-3
RTECS #: XS5250000
% Wt: 13-23
OSHA PEL: 200 PPM; Z-2
ACGIH TLV: S, 50 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 108-10-1
RTECS #: SA9275000
VP:18 @ 20C
% Wt: 4-14
OSHA PEL: 100 PPM
ACGIH TLV: 50 PPM/75 STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 108-65-6
RTECS #: AI8925000
ESTER ACETATE). VP:3.7 @ 20C
% Wt: 1-8
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 78-93-3
RTECS #: EL6475000
% Wt: 1-8
OSHA PEL: 200 PPM
ACGIH TLV: 200 PPM/300 STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 71-36-3
RTECS #: EO1400000
% Wt: 1-8
OSHA PEL: 100 PPM
ACGIH TLV: S, C 50 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 117-81-7
RTECS #: TI0350000
(CERCLA)
% Wt: 1-10
OSHA PEL: 5 MG/M3
ACGIH TLV: 5 MG/M3
EPA Rpt Qty: 100 LBS
DOT Rpt Qty: 100 LBS
------------------------------
Cas: 9004-70-0
RTECS #: QW0970000
% Wt: 1-18
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
% Wt: 1-9
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
RTECS #: 9999999VO
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
EXPLO PROOF EQUIP. KEEP AWAY FROM HEAT, SPKS,
-----------------------------
W/ADEQUATE VENTILATION. "EMPTY" CNTNRS RETAIN
-----------------------------
PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL, GRIND
-----------------------------
IGNIT. DO NOT ATTEMPT TO CLEAN SINCE
-----------------------------
DRAINED, PROPERLY RETURNED TO A DRUM
-----------------------------
MANNER AND I/A/W GOVT REGS. FOR WORK ON
-----------------------------
GOVERNMENTAL AND INDUSTRIAL REFERENCE PERTAINING
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: TOLUENE APPEARS ON THE NAVY LISTING OF OCCUP CHEM REPROD
HAZARDS. SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST
HAZARD LIST INFO & SAFE HNDLG & EXPOS INFO (FP N). ACUTE:INHAL:ANES
THETIC. IRRIT OF RESP TRACT/ACUTE NERV SYS DEPRESS, CHARACT BY HDCH, DIZZ,
STAGG GAIT, CONFUSN, UNCON (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: PHTHALIC ACID, BIS(2-ETHYLHEXYL)ESTER:IARC
MONO, SUPP, VOL 7, PG 56, 1987:GRP 2B. NTP 7TH ANNUAL RPT ON CARCINS,(SUPDAT)
Signs And Symptions Of Overexposure: HLTH HAZ:OR COMA. SKIN/EYE:IRRITANT. RPTS
HAVE ASSOC RPTD & PRLNGD OCCUP EXPOS TO SOLVS W/PERM BRAIN & NERV SYS
DMG. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING MATL MAY
BE HARMFUL/FAT AL. TOLUENE:PRDCED CARD SENSIT. OVEREXPTO TOLUENE:HAS BEEN
FOUND TO CAUSE FOLLOWING EFTS IN LAB ANIMALS:LIVER (SUPDAT)
Medical Cond Aggravated By Exposure: NONE KNOWN.
First Aid: EYE:IMMED FLUSH W/POTABLE WATER FOR AT LEAST 15 MINS, SEEK
ASSISTANCE FROM MD (FP N). INHAL:REMOVE TO FRESH AIR. GIVE OXYGEN IF
BREATHING IS DIFFICULT. CALL PHYS. SKIN:WASH AFFECTED AREAS W/WATER. REM OVE
CONTAMINATED CLOTHING, AND LAUNDER BEFORE REUSE. CONSULT PHYS. INGEST:CALL
PHYS/POIS CTL CTR IMMED. IF CONSCIOUS GIVE 1-2 GLASSES OF WATER. DO NOT
INDUCE VOMITING.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL IGNIT SOURCES. MOP UP SPILLS/ADD ABSORB.
USE NON-SPARKING TOOLS. USE ADEQ VENT. MOVE LEAKING CNTNRS OUTDOORS,
OBSERVING PRECAUTIONS W/REGARD TO FIRE, SPK & FLAME HAZ. RUN-OFF TO
WATERWAY CR EATES FIRE HAZARDS; NOTIFY FIRE & HLTH AGENCIES.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: RECLAIM MATERIAL, INCINERATE, OR USE SANITARY LANDFILL
METHOD OF DISPOSAL, IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.
DO NOT INCINERATE CLOSED CONTAINERS. SEAL DRUM TIGHTLY.
Handling And Storage Precautions: STORE IN WELL-VENTILATED WAREHOUSE. KEEP OUT
OF DIRECT SUNLIGHT OR OTHER HEAT SOURCE. KEEP CONTAINERS CLOSED. NO SMOKING.
Other Precautions: DO NOT TAKE INTERNALLY; HARMFUL/FATAL IF SWALLOWED. CNTNRS
SHOULD BE GROUNDED WHEN POURING. AVOID FREE FALL OF LIQ IN EXCESS OF FEW
INCHES. CLOSE CNTNR AFTER EACH USE. DO NOT TRANSFER CONTENTS TO BOTT
LES/OTHER UNLBLD CNTNRS. AVOID (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 49.0F,9.4C
Lower Limits: 1.4%
Extinguishing Media: FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER
FOG.
Fire Fighting Procedures: NIOSH APPRVD SCBA & FULL PROTECTIVE EQUIPMENT (FP
N). WATER MAY BE INEFTIVE; HOWEVER, USE WATER SPRAY TO COOL FIRE-EXPOSED CLSD
CNTNRS. AVOID EXPOS TO FUMES.
Unusual Fire/Explosion Hazard: TOXIC GASES WHEN BURNING. KEEP CNTNRS TIGHTLY
CLSD. ISOLATE FROM HEAT, SPKS, OPEN FLAME & STATIC ELEC. CLSD CNTNRS MAY
EXPLODE WHEN EXPOSED TO EXTREME (SUPAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: WEAR PROPERLY FITTED, NIOSH APPROVED RESPIRATOR DURING
AND AFTER APPLICATION UNLESS AIR MONITORING DEMONSTRATES VAPOR/MIST LEVELS
ARE BELOW ACCEPTABLE LIMITS.
Ventilation: USE APPROVED SPRAY BOOTH. PROVIDE GEN DILUTION/LOC EXHAUST
VENTILATION IN VOL & PATTERN TO KEEP CONCS BELOW TLV.
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: NONE REQUIRED.
Supplemental Safety and Health: EXPLO HAZ:HEAT. WATER MAY BE USED TO COOL CLSD
CNTNRS. DO NOT APPLY TO HOT SURFS. EXPLAN OF CARCIN:1994:ANTIC TO BE
CARCIN.ANIMAL:LIVER, TESTES. EFTS OF OVEREXP:ABNORM, KIDNEY DMG, LUNG DMG,
SPLEEN DM G. HUMAN:LIVER ABNORM. FOR MORE INFO CONCERNING HLTH HAZ CONT NEHC
(FP N). OTHER PREC:PRLNGD CONT W/SKIN & BRTHG
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >176F,>80C
Vapor Pres: SEE INGS
Vapor Density: HVR/AIR
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: NOT KNOWN
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 41
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: TEMPERATURES IN EXCESS OF 150F IN CLOSED
CONTAINER. EXPOSURE TO HEAT, SPARKS, OPEN FLAME AND HOT SURFACES.
Materials To Avoid: OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE, OXIDES OF
NITROGEN.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: BL-217; ANTIQUE IVORY BRUSHING LACQUER
Cage: 35178
Company Name: LASTING PAINTS INC.
Street: 200 S FRANKLINTOWN RD
Zipcode: 21223-2038
Label Required IND: Y
Date Of Label Review: 06/02/1997
Status Code: C
Label Date: 06/02/1997
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE LIQUID CLASS 1B. ACUTE:INHALATION:ANESTHETIC.
IRRITATION OF RESPIRATORY TRACT OR ACUTE NERVOUS SYSTEM DEPRESSSION WITH
HEADACHE, DIZZINESS, STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS, OR CO MA.
SKIN OR EYE CONTACT:PRIMARY IRRITANT. CHRONIC:CANCER HAZARD. CONTAINS
PHTHALIC ACID, BIS(2-ETHYLHEXYL) ESTER WHICH IS LISTED AS AN ANIMAL LIVER
CARCINOGEN (FP N). TOLUENE APPEARS ON THE NAVY OCCUP ATIONAL CHEMICAL
REPRODUCTIVE HAZARDS LIST (FP N). OVEREXPOSURE TO SOLVENTS HASBEEN REPORTED
TO CAUSE PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CALCIUM NITRATE
CAGE:62910
CAGE:62910
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM NITRATE TETRAHYDRATE; CAS #13477-34-4
CAS:10124-37-5
RTECS #:EW2985000
Fraction by Wt: >99%
===================== Hazards Identification =====================
Effects of Overexposure:INH:MAY IRRIT RESP
TRACT;ING:IRRITANT/CORROSIVE,NAUSEA,VOMITG;SKIN/EYES:IRRITANT,POSS
CORROSIVE.
======================= First Aid Measures =======================
First Aid:INHAL:RMV TO FRESH AIR.GIVE CPR/OXYGEN IF BREATHING IS
DIFFICULT.GET MD;INGEST:IMMED INDUCE VOMIT BY GIVING 2 GL OF
WATER.NOTHING BY MOUTH IF UNCONSCIOUS.GET MD IMMED;SKIN/EYES:FLUSH
IMMED W/LG QTY H* 2O FOR 15 MIN.RMV CONTMNTD CLOTHES.GET MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CNTD BRTHG,APP H*20 SPRAY TO COOL
CONTR.
Unusual Fire/Explosion Hazard:CAN CAUSE EXPLOSIONS IN CONTACT
W/COMBUSTBL DUST/VAP;OCCASIONALLY EXPLOSV BY SHOCK OR FRICTION.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF SPILL.CLEAN UP PERSONS NEED
PROTCTV CLOTHG/RESP PROTCTION FM DUST.PICK UP SPILL & PLACE IN A
SUITABLE CONTAINER FOR RECLAMATION OR DISPOSAL IN A METHOD THAT
DOES NOT GENERATE DUST(VA CUUMING OR WET SWEEPING MAY BE USED TO
AVOID DUST)
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN TIGHTLY CLOSED CONTNRS AT
COOL,DRY,VENTILATED PLACE.PROTECT AGAINST PHY DAMAGE.DO NOT STORE
ON WOODEN FLOORS.ISOLATE FROM FLAMMABLES.
Other Precautions:AVOID BREATHING DUST.USE W/ADEQUATE VENTILATION.KEEP
CONTAINRS CLOSED.WASH THOROUGHLY AFTER HANDLING.AVOID SKIN,EYES &
CLOTHING CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR RESPIR/SCBA; ESCAPE: GAS MASK
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:FULL PROTECTIVE CLOTHING,SAFETY SHOWER,EYE
WASH STATION
Supplemental Safety and Health
MSDS FM MFR DATED:16 AUG 85;MSDS CONFORMS TO OSHA HAZ COMM STD FORMAT;
MELTING POINT:45C(113F)
================== Physical/Chemical Properties ==================
HCC:D1
Spec Gravity:2.36
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS CRYSTALS,DELIQUESCENT.ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AMMONIA HYDROZINE,REDUCING SUBSTANCES & FLAMMABLE MATL
Stability Condition to Avoid:NOT KNOWN
Hazardous Decomposition Products:OXIDES OF NITROGEN & CALCIUM
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECLAMATION MAY BE
DISPOSD AS HAZ WASTE IN A RCRA APPRVD WASTE DISPOSAL
FACILITY.COMPLY WITH LOCAL,ST.& FED REGS; PER MFR,SMALL AMOUNTS OF
RESIDUE MAY BE FLUSHED TO SEWER WITH PLENTY OF WATER.
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.