text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:TOLUENE
CAGE:90879
DIV
CAGE:90879
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 100%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS 7.53 ML/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGEST- PULMONARY ASPIRATION
HAZARD IF SWALLOWED AND VOMITING OCCURS. EYE- CONTACT MAY CAUSE
MODERATE TO SEVERE IRRITATION. INHALE- IRRITATION TO EYES, NOSE,
CNS. CHRONIC: INHALE- REPEATED EXCE SSIVE EXPOSURES MAY CAUSE
CHRONIC, ADVERSE SYSTEMIC EFFECTS. SKIN- MODERATE IRRITATION AND
DEFATTING.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:DIZZINESS, LOSS OF BALANCE AND COORDINATION,
UNCONSCIOUSNESS, COMA, RESPIRATORY FAILURE AND DEATH.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION.
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH. GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:40.0F,4.4C
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. NONE
SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS. FLAMMABLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION AND
FLAMMABLES. ABSORB SPILL ON SAND, EARTH OR VERMICULITE. CAREFULLY
SWEEP UP AND REMOVE. ALLOW TO EVAPORATE. FLUSH SPILL AREA WITH
WATER.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING. FOR
INDUSTRIAL USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED ORGANIC VAPOR
CARTRIDGE AND DUST/MIST PRE-FILTER RESPIRATORS AS PER CURRENT 29
CFR 1910.134, INSTRUCTIONS/ WARNINGS AND NIOSH-RESPIRATOR
SELECTION.
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION IS NORMALLY ADEQUATE.
LOCAL EXHAUST MAY BE REQUIRED IF WORK AREA NOT VENTED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER. WEAR
IMPERVIOUS PROTECTIVE GEAR.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:232F,111C
Melt/Freeze Pt:M.P/F.P Text:-139F,-95C
Vapor Pres:36.7
Vapor Density:3.14
Spec Gravity:0.87
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS, REFRACTIVE LIQUID WITH BENZENE-LIKE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE AND ASPHYXIANTS. NONE
SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. ATOMIZE
INTO AN INCINERATOR PROVIDING ENVIRONMENTAL REGULATIONS PERMIT.
COMBUSTION MAY BE IMPRO VED BY MIXING W/ MORE FLAMMABLE SOLVENT.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TRADEWINDS
Preparer's Name:RICHARD J. PETSCHE
CAGE:HO278
CAGE:HO278
CAGE:58380
============= Composition/Information on Ingredients =============
Ingred Name:NONHAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE IRRITATION TO SKIN
AND EYES. INGEST: MAY CAUSE IRRITATION TO GI SYSTEM. LOW ORDER OF
TOXICITY. CHRONIC: NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:EYES: TEARING, REDNESS. SKIN: REDNESS. INGEST:
IRRITATION.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MIN. SEEK
MED ATTN. SKIN: FLUSH WITH WATER. INGEST: DRINK LARGE AMOUNTS OF
WATER AND INDUCE VOMITING. INHAL: REMOVE TO FRESH AIR. SUPPORT
BRTHG (GIVE O *2/ARTF RESP) .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>210F,>99C
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP WITH RAGS AND TOWELS. WASH AREA WITH
WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY PLACE. DO NOT STORE
NEAR HEAT OR OPEN FLAME. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:FOR INDUSTRIAL & INSTITUTIONAL USE ONLY. READ &
FOLLOW ALL LABEL DIRECTIONS AND PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST: NORMAL.
Other Protective Equipment:NONE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:120F,49C
Vapor Density:>1
Spec Gravity:0.96(H*2O=1)
Evaporation Rate & Reference:>1(BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CONTAINERIZED GEL WITH APPLE FRAGRANCE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS SUCH AS NITRIC ACID.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:USE NORMAL GARBAGE OR WASTE DISPOSAL SERVICE.
FOLLOW FEDERAL, STATE, AND LOCAL DISPOSAL REGULATIONS. THIS
MATERIAL IS NOT AN EPA HAZARDOUS WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MARCOLOY 65
CAGE:55278
CAGE:55278
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MANGANESE (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:5 MG/M3 DUST, C
ACGIH TLV:5 MG/M3 DUST
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:TUNGSTEN, AS W, SOLUBLE COMPOUNDS; (TUNGSTEN)
CAS:7440-33-7
RTECS #:YO7175000
OSHA PEL:N/K
ACGIH TLV:1 MG/M3;3 STEL
Ingred Name:COBALT (SARA 313)
CAS:7440-48-4
RTECS #:GF8750000
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.02 MG/M3
Ingred Name:BORON
CAS:7440-42-8
RTECS #:ED7350000
OSHA PEL:10 MG/M3 (B2O3)
ACGIH TLV:10 MG/M3 (B2O3)
Ingred Name:ALUMINUM (SARA 313)
CAS:7429-90-5
RTECS #:BD0330000
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM FLUORIDE (AS F); (FLUORIDE)
CAS:7789-75-5
RTECS #:EW1760000
OSHA PEL:2.5 MG/M3 (MFR)
ACGIH TLV:2.5 MG/M3 (MFR)
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CRYOLITE; (SODIUM ALUMINUM FLUORIDE)
CAS:15096-52-3
RTECS #:WA9625000
OSHA PEL:N/K
ACGIH TLV:2.5 MG/M3 (MFR)
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
OSHA PEL:N/K
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:SUPDAT:WELDERS & VOL OF WORK AREA, QUALITY & AMT OF VENT,
POSITION OF WELDER'S HEAD W/RESPECT TO FUME PLUME & (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:PRESENCE OF CONTAMS IN ATM (SUCH AS CHLORINATED
HYDROCARBON VAPS). DECOMP PRODS OF NORMAL OPERATION INCL (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:THOSE ORIGINATING FROM VOLAT, RXN/OXIDATION OF INGS
& THOSE FROM BASE METAL & COATING. GASEOUS RXN PRODS (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:MAY INCL CARBON MONOXIDE & CARBON DIOXIDE. OZONE &
NITROGEN OXIDES MAY BE FORMED BY RADIA FROM ARC. ONE (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:WAY TO DETERMINE COMPOSITION OF QTY OF FUMES & GASES
IS TO TAKE AN AIR SAMPLE FROM INSIDE WELDER'S HELMET(ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21:OR IN WORKER'S BRTHG ZONE. FOR MORE SPECIFIC
INFORMATION CONTACT NEHC .
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN:ON CARCINS, 1994:ANTIC TO BE CARCIN.
ANIMAL:LUNGS, NASAL CAVITIES. COBALT:IARC MONOGRAPHS ON (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23:EVAL OF CARCIN RISK OF CHEMS TO MAN, VOL 52, PG 363,
1991:GRP 2B. ANIMAL:PULM FIBROSIS (BLOOD EFTS).
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP:PROTECTION, AS WELL AS DARK SUBSTANTIAL
CLOTHING. FOR MORE SPECIFIC INFORMATION CONTACT NEHC .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ELECTRIC ARC-WELDING MAY CREATE ONE OR
MORE OF THE FOLLOWING HEALTH HAZARDS:FUMES & GASES CAN BE DANGEROUS
TO YOUR HEALTH. ARC RAYS CAN INJURE EYES & BURN SKIN. ELECTRIC
SHOCK CAN KILL. ACUTE:SHORT-TE RM OVEREXPOSURE TO WELDING FUMES MAY
RESULT IN DISCOMFORT SUCH AS: DIZZINESS, NAUSEA, DRYNESS OR(EFTS OF
OVEREXP)
Explanation of Carcinogenicity:NICKEL:IARC MONOGRRAPHS ON EVAL OF
CARCIN RISK OF CHEMS TO MAN, VOL 49, GP 257, 1990:GRP 2B. NTP 7TH
ANNUAL RPT (ING 23)
Effects of Overexposure:HLTH HAZ:IRRITATION OF NOSE, THROAT OR EYES,
TIGHTNESS IN CHEST, FEVER & ALLERGIC REACTIONS. CHRONIC:LONG-TERM
OVEREXPOSURE TO WELDING FUMES MAY LEAD TO SIDEROSIS (IRON DEPOSITS
IN LUNGS) & IS BELIEVE D BY SOME INVESTIGATORS TO AFFECT PULMONARY
FUNCTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:REMOVE TO FRESH AIR, OBTAIN MEDICAL ATTENTION. EMPLOY FIRST
AID TECHNIQUES RECOMMENDED BY THE AMERICAN RED CROSS. INGEST:CALL
MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
O*2/ARTF RESP) . EYES:IMMEDIATELYFLUSH W/POTABLE WATER FOR A
MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD . SKIN:FLUSH
W/COPIOUS AMOUNTS OF WATER. CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS CAN IGNITED
COMBUSTIBLES & FLAMMABLES. REFER TO ANSI Z49.1 FOR FIRE PREVENTION
DURING THE USE OF WELDING & ALLIED PROCEDURES.
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:TRAIN WELDER TO KEEP HIS HEAD OUT OF
FUMES. TRAIN WELDER NOT TO TOUCH LIVE ELECTRICAL PARTS & TO
INSULATE HIMSELF FROM WORK & GROUND.
Other Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS & PREC LABEL ON
PROD. USE EXHAUST SYS TO CLEAR WELDING FUMES. MAKE SURE THAT
INHALED AIR DOES NOT CNTN FUME CONSTITUENTS ABOVE PELS. FOR MORE
SPECIFIC INFORMATION CONTACT NEHC .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME NIOSH APPROVED RESPIRATOR OR
AIR SUPPLIED RESPIRATOR WHEN WELDING IN A CONFINED SPACE OR WHERE
LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE BELOW THE
RECOMMENDED EXPOSURE LI MIT.
Ventilation:USE ENOUGH VENT, LOCAL EXHAUST AT THE ARC, OR BOTH, TO KEEP
FUMES & GASES FROM WORKER'S BRTHG ZONE & THE GENERAL AREA.
Other Protective Equipment:ANSI APPROVED EYE WASH FOUNTAIN & DELUGE
SHOWER . THIS MAY INCLUDE ARM PROTECTORS, APRONS, HATS, SHOULDER
(ING 25)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EYE PROT:FULL LGTH FCSHLD W/FILTER LENS. PROVIDE PROT SCREENS & FLASH
GOGGS, IF NEC, TO SHIELD OTHERS. AS RULE OF THUMB START W/SHADE
THAT IS TOO DARK TO SEE WELD ZONE. THEN GO TO NEXT LIGHTERSHADE
WHICH GIVES SUFFICIENT VIEW OF WELD ZONE. HAZ DECOMP PROD:USED,
COATINGS ON METAL BEING WELDED, NUMBER OF (ING 17)
================== Physical/Chemical Properties ==================
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE, UNLESS OTHERWISE SPECIFIED.
Hazardous Decomposition Products:COMPOSITION & QUALITY OF WELDING FUMES
& GASES ARE DEPENDENT UPON METAL BEING WELDED, PROCESS, PROC &
ELECTRODES(SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
W/FEDERAL, STATE & LOCA L REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-251-3980
Product ID: 76764 ANTI-SEIZE LUBRICANT THREAD COMPOUND 767
Cage: 7K128
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 7K128
=======================================================
Contractor Summary
=======================================================
Cage: 7K128
Cage: 05972
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: ANTISEIZE COMPOUND
Unit of Issue: LB
UI Container Qty: 1
=======================================================
Ingredients
=======================================================
Cas: 64742-52-5
RTECS #: PY8035001
PETROLEUM DISTILLATES, MINERAL OIL (SEVERE)
% Wt: 40-50
------------------------------
Cas: 7440-50-8
RTECS #: GL5325000
% Wt: 10-15
Other REC Limits: 1 MG(CU)/M3 (DUST)
OSHA PEL: 0.1 MG(CU)/M3 (FUME)
ACGIH TLV: 0.2 MG/M3 (FUME)
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 64741-44-2
RTECS #: LX3296000
% Wt: 10-15
ACGIH TLV: 5 MG/CUM
------------------------------
Cas: 7429-90-5
RTECS #: BD0330000
% Wt: 5-10
OSHA PEL: 15 MG/CUM
ACGIH TLV: 10 MG/CUM (DUST)
------------------------------
Cas: 64742-53-6
RTECS #: PY8036000
% Wt: 0-10
------------------------------
Cas: 7782-42-5
RTECS #: MD9659600
% Wt: 1-3
Other REC Limits: 2.5MG/CUM
ACGIH TLV: 2 MG/CUM RESP IC
------------------------------
Cas: 7620-77-1
% Wt: 1-3
------------------------------
Cas: 112926-00-8
RTECS #: VV7315000
SILICA GEL *98-3*
% Wt: 1-3
ACGIH TLV: 10 MG/CUM
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES/SKIN: IRRITANT. INHALATION: MAY IRRITATE/BURN NOSE,
THROAT, MUCOUS MEMBRANE. INGESTION: DIGESTIVE TRACT IRRITANT/NERVOUS SYSTEM
DEPRESSION. COPPER-SKIN: SENSITIZATION/DERMATITIS. MAY AFFECT THE R
ESPIRATORY SYSTEM/NASAL SEPTUM/SKIN/EYES/GI SYSTEM/KIDNEYS/LIVER &
CARDIOVASCULAR SYSTEM.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, BURN. COPPER-VOMITING,
COLLAPSE, METAL-FUME FEVER, METALLIC TASTE, DISCOLORATION OF SKIN & HAIR,
HEMOLYSIS, JAUNDICE, ANURIA, HYPOTENSION, CONVULSIONS.
Medical Cond Aggravated By Exposure: GRAPHITE POWDER-EMPHYSEMA, ASTHMA, OTHER
RESPIRATORY PROBLEMS.
First Aid: INGESTION: DON'T INDUCE VOMITING. KEEP CALM. INHALATION: OIL
MIST-REMOVE TO FRESH AIR. SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/WATER
FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE IGNITION SOURCES. TAKE UP W/AN INERT
ABSORBENT. STORE IN A CLOSED CONTAINER UNTIL DISPOSAL.
Waste Disposal Methods: INCINERATE IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS. DON'T INCINERATE PRESSURIZED CANS.
Handling And Storage Precautions: KEEP AWAY FROM IGNITION SOURCES & HOT
SURFACES. KEEP AWAY FROM EYES. AVOID PROLONGED SKIN CONTACT. AVOID PROLONGED
BREATHING OF VAPORS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: NONE
Lower Limits: 1 (GAS OIL)
Upper Limits: 7 (GAS OIL)
Extinguishing Media: CO2, FOAM, DRY CHEMICAL.
Unusual Fire/Explosion Hazard: NONE
=======================================================
Control Measures
=======================================================
Ventilation: ADEQUATE LOCAL VENTILATION TO MAINTAIN VAPOR CONCENTRATION
<TLVS IF MISTING OF OIL OCCURS/COMPOUND BECOMES DRY.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V7
B.P. Text: >500F
Vapor Pres: <5
Vapor Density: 2.9
Spec Gravity: 1.1242
VOC Grams/Liter: 122
Solubility in Water: INSOLUBLE
Appearance and Odor: GREY GREASE W/PETROLEUM ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: IGNITION SOURCES & HOT SURFACES.
Materials To Avoid: STRONG OXIDIZERS, ALKALIES, MINERAL ACIDS, SELECTED AMINES.
Hazardous Decomposition Products: BY FIRE: METAL VAPORS, OXIDES OF CARBON,
NITROGEN, BARIUM, ZINC, SULFUR, HYDROGEN SULFIDE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC CONTENT: 122 G/L/10.66%
=======================================================
HAZCOM Label
=======================================================
Product ID: 76764 ANTI-SEIZE LUBRICANT THREAD COMPOUND 767
Cage: 7K128
Company Name: LOCTITE CORP
Street: 705 N MT RD
Zipcode: 06111
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: EYES/SKIN: MAY CAUSE IRRITATION. INHALATION: MAY
IRRITATE/BURN NOSE & THROAT. INGESTION: MAY CAUSE DIGESTIVE TRACT
IRRITATION & NERVOUS SYSTEM DEPRESSION. COPPER-SKIN: SENSITIZATION
DERMATITIS. EYES: IRRITATION. INHALATION: MUCOUS MEMBRANEIRRITATION.
IRRITATION, BURN.
COPPER-VOMITING, COLLAPSE, METAL-FUME FEVER, METALLIC TASTE, DI SCOLORATION
OF SKIN & HAIR, HEMOLYSIS, JAUNDICE, ANURIA, HYPOTENSION, CONVULSIONS.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:40-6325-008, MICROPOLISH II
Preparer's Name:THOMAS R. DERAM
CAGE:09410
CAGE:09410
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE (2:3); (ALPHA-ALUMINA) (EPA LISTS ONLY
FIBROUS FORMS) (SARA III)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 100%
Other REC Limits:15 MG/M3 (MFR)
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: MAY CAUSE IRRITATION OF THE
NOSE & THROAT ACCOMPANIED BY COUGH & CHEST PAIN. EYE:MAY CAUSE
IRRITATION SEEN AS REDNESS & POSSIBLY SWELLING OF THE CONJUNCTIVA.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NO EVIDENCE OF ADVERSE EFFECTS FROM AVAILABLE
INFORMATION.
Medical Cond Aggravated by Exposure:OVEREXPOSURE: BREATHING OF DUST MAY
AGGRAVATE ASTHMA & INFLAMMATORY OR FIBROTIC PULMONARY DISEASE.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH THOROUGHLY W/WATER FOR AT LEAST 15 MINS. SKIN:WASH
W/SOAP & WATER. INHAL:REMOVE TO FRESH AIR. GIVE OXYGEN IF NEEDED.
INGEST:RINSE MOUTH W/WATER.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT TO PROTECT AGAINST
HAZARDS & DISPOSE OF PER WASTE DISPOSAL METHOD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
USE W/ADEQUATE VENTILATION. AVOID AGITATION & OPEN CONTAINERS TO
AVOID DUSTING OF POWDER.
Other Precautions:NONE KNOWN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF THERE IS EXCESSIVE DUSTINESS, WEAR NIOSH/MSHA
APPROVED RESPIRATOR PER OSHA 29CFR1910.134.
Ventilation:LOCAL EXHAUST: LOCAL DUST PICKUP RECOMMENDED.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:GOOD PEROSNAL HYGIENE TO BE FOLLOWED AT ALL
TIMES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:3.99 (H2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE DUSTY POWDER W/NO APPRECIABLE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ETHYLENE OXIDES & CHLORINE TRIFLUORIDE.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE PER LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PENTANE, T007
CAGE:DO803
CAGE:DO803
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:PENTANE
CAS:109-66-0
RTECS #:RZ9450000
Fraction by Wt: 90-100%
OSHA PEL:1000 PPM
ACGIH TLV:600 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION OF VAPORS MAY CAUSE
NARCOSIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . EYES:IMMEDIATELY FLUSH W/POTABLE
WATER FOR A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD .
SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . INHALATION :REMOVE
TO FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN.
===================== Fire Fighting Measures =====================
Flash Point:-40F,-40C
Lower Limits:1.4%
Upper Limits:8.0%
Extinguishing Media:USE ALCOHOL FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
(WATER MAY BE INEFFECTIVE).
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
MOVE EXPOSED CNTNRS FROM FIRE AREA IF IT CAN BE DONE W/OUT RISK.
USE WATER TO KEEP FIRE-EXPOSED CNTNRS COOL.
Unusual Fire/Explosion Hazard:VAPS MAY FLOW ALONG SURF TO DIST IGNIT
SOURCES & FLASH BACK. CLSD CNTNRS EXPOSED TO HEAT MAY EXPLODE. CONT
W/STRONG OXIDIZERS MAY CAUSE FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROT CLTHG. SHUT OFF IGNIT
SOURCES; NO FLARES, SMKG/FLAMES IN AREA. STOP LEAK IF YOU CAN DO SO
W/OUT RISK. USE WATER SPRAY TO REDUCE VAPS. TAKE UP W/SAND/OTHER
NON-COMBUST ABSORB MATL & PLACE INTO CNTNRS FOR LATER DISP.
FLUSH(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DANGER! EXTREMELY FLAMMABLE. HARMFUL
IF INHALED. KEEP AWAY FROM HEAT, SPARKS, FLAME. AVOID BREATHING
VAPOR. KEEP IN TIGHTLY CLOSED CONTAINER.
Other Precautions:USE WITH ADEQUATE VENT. BOND AND GROUND CONTAINERS
WHEN TRANSFERRING LIQUID. KEEP CONTAINER TIGHTLY CLOSED. STORE IN A
COOL, DRY, WELL-VENTILATED, FLAMMABLE LIQUID STORAGE AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESP PROT REQ IF AIRBORNE CONC EXCEEDS TLV. AT
CONCS UP TO 5000 PPM, NIOSH/MSHA APPRVD CHEM CARTRIDGE RESP W/ORG
VAP CARTRIDGE IS RECOM. ABOVE THIS LEVEL, A NIOSH/MSHA APPRVD SCBA
IS RECOMMENDED.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL PROC:AREA WITH WATER. J. T. BAKER SOLUSORB SOLVENT ABSORBENT IS
RECOMMENDED FOR SPILLS OF THIS PRODUCT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:97.0F,36.1C
Melt/Freeze Pt:M.P/F.P Text:-202F,-130C
Vapor Pres:400
Vapor Density:2.5
Spec Gravity:0.62 (H*2O=1)
Evaporation Rate & Reference:28.5 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE (<0.1%)
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH MILD ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, FLAME, SOURCES OF IGNITION.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:810853, STARFIX FIXER, PART A
Kit Part:Y
CAGE:OLINH
CAGE:73877
CAGE:OLINH
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID (SARA III)
CAS:64-19-7
RTECS #:AF1225000
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:OTHER COMPONENTS(UNIDENTIFIED COMPONENTS)
===================== Hazards Identification =====================
Effects of Overexposure:EYES/SKIN: MAY CAUSE IRRITATION.REPEATED OR
PROLONGED SKIN CONTACT MAY CAUSE ALLERGIC REACTION.
======================= First Aid Measures =======================
First Aid:SKIN-REMOVE CONTAMINATED CLOTHING,WASH WITH SOAP &
WATER.EYES-FLUSH WITH WATER FOR 15 MIN.IF DISCOMFORT PERSISTS,GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:WEAR SELF-CNTD BRTHG,APP H*20 SPRAY TO COOL
CONTR.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES OF OXIDES OF SULFUR
WHEN HEATED TO DECOMPOSITION
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. STOP LEAK.
EVACUATE AREA.DO NOT TOUCH SPILLAGE. SM SPILL:ABSORB W. INERT
ABSORBENT. PLACE IN CLOSED CONTAINER. FLUSH AREA W. WATER. LG
SPILL: DIKE AHEAD FOR LATER DISPOSAL. NOTIFY AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:AVOID CONTACT WITH EYES.WASH THOROUGHLY AFTER
HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT NEEDED
Ventilation:LOCAL RECOMMENDED
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS & LEGS.
Supplemental Safety and Health
MSDS FM MFR DATED:5/10/79; APPROX PH:5.1;KEY1:C3.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:212F/100C
Vapor Pres:15
Spec Gravity:1.35
Evaporation Rate & Reference:1.0,WATER
Solubility in Water:COMPLETE
Appearance and Odor:PALE AMBER LIQUID HAVING ODOR OF ACETIC ACID
Percent Volatiles by Volume:37
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS,ALKALIES,OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:OXIDES OF SULFUR,AMMONIA
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL QUANTITIES MAY BE DILUTED WITH WATER &
FLUSHED TO DRAIN.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRIMERS, B50WZ1 KROMIK WHITE
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA 313) (CERCLA) VP: 22.0
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 3%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENE, ETHYL-; (ETHYLBENZENE) (SARA 313) VP: 7.1
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 2%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/125STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (SARA 313) (CERCLA) VP: 5.9
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 11%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (LIGHT
AROMATIC HYDROCARBONS) VP: 3.8
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MESITYLENE; (1,3,5-TRIMETHYLBENZENE) VP: 10.0
CAS:108-67-8
RTECS #:OX6825000
Fraction by Wt: 2%
OSHA PEL:25 PPM (MFR)
ACGIH TLV:25 PPM (MFR)
Ingred Name:BENZENE, 1,2,4-TRIMETHYL-; (1,2,4-TRIMETHYLBENZENE) (SARA
313) VP: 2.0
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 4%
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:2-PENTANONE; (METHYL N-PROPYL KETONE) VP: 27.8
CAS:107-87-9
RTECS #:SA7875000
Fraction by Wt: 1%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/250STEL
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
CAS:14807-96-6
RTECS #:MW2710000
Fraction by Wt: 4%
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBER/CC,A1
Ingred Name:CARBONIC ACID, CALCIUM SALT (1:1); (CALCIUM CARBONATE)
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 18%
OSHA PEL:15 PPM (MFR)
ACGIH TLV:10 PPM (MFR)
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 7%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 11%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:VOLATILE ORGANIC CONTENT 3.29 LBS/GAL
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WASTE DISP METH: DISPOSE IF IN ACCORDANCE WITH FEDERAL,
STATE, AND LOCAL REGULATIONS REGARDING POLLUTION.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: CONTRS W/COMPLETE & APPROP LABELING. DO NOT
TAKE INTERNALLY. KEEP OUT OF THE REACH OF CHILDREN. (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: INTENTIONAL MISUSE BY DELIBERATELY CONC & INHAL
CONTENTS CAN BE HARMFUL/FATAL. USE ONLY W/ADEQ VENT. (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: AVOID BRTHG VAP & SPRAY MIST. AVOID CONT W/SKIN &
EYES. WASH HANDS AFTER USING. COATING MAY CONTAIN (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: MATLS CLASIFIED AS NUISANCE PARTICULATES WHICH MAY
BE PRESENT AT HAZ LEVELS ONLY DURING SANDING/ (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: ABRADING OF DRIED FILM. IF NO SPECIFIC DUSTS ARE
LISTED IN ING SECTION, APPLIC LIM FOR NUISANCE DUSTS (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: ARE ACGIH TLV 10 MG/M3 (TOTAL DUST), OSHA PEL 15
MG/M3 (TOTAL DUST), 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ
Ingred Name:RESP PROT: PARTICULATE RESP APPRVD BY NIOSH/MSHA FOR PROT
AGAINST NON-VOLATILE MATERIALS IN INGREDIENT SECTION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT TO EYES, SKIN & RESP SYS.
MAY CAUSE CNS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON & POSS
DEATH. PRLNG OVEREXP TO SOLV INGS MAY CAUSE ADVERSE EFTS TO LIVER,
URINARY & REPRO SYS. CHRONIC: REPORTS HAVE ASSOC RTPD & PRLNG
OVEREXPTO SOLV W/PERM BRAIN & CNS DMG. TOLUENE APPEARS ON NAVY LIST
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: OF OCCUP CHEM REPRO HAZ. SEEK CONSULT
FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO &
SAFE HNDLG & EXPOS INFO . HDCH, DIZZ, NAUS, & LOSS OF COORD ARE
INDICATIONS OF EX CESS EXPOS TO VAPS/SPRAY MISTS. REDNESS&
ITCH/BURNING SENSATION MAY INDICATE EYE/EXCESS SKIN EXPOS.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM AND
QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. EYES: FLUSH
WITH LA RGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
ATTENTION. INGEST: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:80.0F,26.7C
Lower Limits:0.7%
Upper Limits:6.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZ ARE
PREFERABLE. WATER MAY BE USED TO (SUP DAT)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS, & OPEN FLAME. CLSD CONTRS MAY EXPLODE
WHEN EXPOSED TO EXTREME HEAT. APPLICATN TO HOT (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAME. DURING USE & UNTIL ALL VAPS ARE GONE, KEEP AREA VENT. DO NOT
SMOKE.
Other Precautions:EXTING ALL FLAMES, PILOT LIGHTS & HEATERS. TURN OFF
STOVES, ELEC TOOLS & APPLIANCES, & ANY OTHER SOURCES OF IGNIT.
CONSULT NFPA CODE. USE APPRVD BONDING & GROUNDING PROC. KEEP CONTR
CLSD WHEN NOT IN U SE. TRANSFER ONLY TO APPRVD (ING 14)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERS EXPOS CANNOT BE CTLD BELOW APPLIC LIM BY
VENT, WEAR PROPERLY FITTED NIOSH/MSHA APPRVD ORG VAP/PARTICULATE
RESP FOR PROT AGAINST MATLS IN ING SECTION. WHEN SANDING,
WIREBRUSHING, ABRADING, BURN ING/WELDING DRIED FILM, WEAR A (ING
20)
Ventilation:LOC EXHAUST PREFERABLE. GEN EXHAUST ACCEPTABLE IF EXPOS TO
MATLS IS MAINTAINED < APPLIC EXPOS LIM. REFER TO (SUP DAT)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC: COOL CLSD CONTRS TO PREVENT PRESS BUILD-UP & POSS
AUTOIGNIT/EXPLO WHEN EXPOSED TO EXTREME HEAT. EXPLO HAZ: SURF
REQUIRES SPECIAL PREC. DURING EMER CNDTNS OVEREXP TO DECOMP PRODS
MAY C AUSE HLTH HAZ. SYMP MAY NOT BE IMMED APPARENT. OBTAIN MD
ATTN. VENT: OSHA STDS 1910.94, 1910.107, 1910.108.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>217F,>103C
Vapor Pres:(SEE INGS)
Vapor Density:HVR/AIR
Spec Gravity:1.24-1.52
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:43-62
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENTS SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
RCRA 40CFR 261. WASTE MUST BE TESTED FOR IGNIT TO DETERMINE APPLIC
EPA HAZ WASTE NUMBERS. MUST ALSO BE TESTED FOR CHROMIUM
EXTRACTABILITY. INCIN IN APP RVD FACILITY. DO NOT INCIN CLSD
CONTRS.(ING 13)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:JP-4
Preparer's Name:J. L. JACKSON
CAGE:4L822
CAGE:4L822
============= Composition/Information on Ingredients =============
Ingred Name:PARAFFINIC HYDROCARBONS
Fraction by Wt: 74-88% %
Other REC Limits:400 PPM PEL
Ingred Name:AROMATIC HYDROCARBON FRACTION
Fraction by Wt: 10-25% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROCARBONS C8 +
Fraction by Wt: 0-.3%
Other REC Limits:400 PPM PEL
Ingred Name:NAPHTHALENE (SARA III)
CAS:91-20-3
RTECS #:QJ0525000
Fraction by Wt: 0-3% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM/15 STEL
ACGIH TLV:10 PPM/15 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:OLEFINS
Fraction by Wt: 1-2% %
Other REC Limits:400 PPM PEL
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: < 4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYE IRRITATION, SKIN IRRITATION,
CENTRAL NERVOUS SYSTEM DEPRESSION, PRODUCT HAS A LOW ORDER OF ACUTE
ORAL TOXICITY, BUT MINUTE AMOUNTS ASPIRATED INTO THE LUNGS DURING
INGESTION MAY CAUSE SEVERE PULMON ARY INJURY OR DEATH.
Explanation of Carcinogenicity:PRODUCT CONTAINS BENZENE WHICH IS LISTED
BY NTP, IARC, AND OSHA.
Effects of Overexposure:EYE IRRITATION, MILD SKIN IRRITATION FOLLOWING
PROLONGED OR FREQUENTLY REPEATED CONTACT, WEAKNESS, HEADACHE,
NAUSEA, CONFUSION, BLURRED VISION, DROWSINESS, DIZZINESS, SLURRED
SPEECH, FLUSHED FACE, UNC ONSCIOUSNESS, CONVULSIONS, PULMONARY
INJURY.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASE IN OR A HISTORY OF AILMENTS INVOLVING THE SKIN OR
RESPIRATORY SYSTEMMAY BE AT GREATER THAN NORMAL RISK WHEN EXPOSED
TO THIS MATERIAL.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATLEY FLUSH WITH FRESH WATER FOR AT LEAST 15
MINUTES. IF IRRITATION PERSISTS, SEE A DOCTOR. SKIN: IMMEDIATELY
WASH THOROUGHLY WITH SOAP AND WATER. IF IRRITATION DEVELOPS, SEE
PHYSICIAN. IN HALATION: REMOVE TO FRESH AIR AND CALL DOCTOR. IF NOT
BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. INGESTION: DO NOT INDUCE VOMITING. CALL A DOCTOR
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:-30F,-34C
Lower Limits:1.4 %
Upper Limits:7.6 %
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICALS, FOAM OR WATER SPRAY
(FOG), VAPORIZING LIQUIDS
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE BUT SHOULD BE USED TO
KEEP CONTAINERS COOL. MINIMIZE BREATHING GASES, VAPOR, FUMES OR
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:HIGHLY FLAMMABLE. VAPORS CAN EXPLODE.
LIQUID EVAPORATES AND FORMS VAPORS WHICH CAN SPREAD EASILY AND CAN
BE SET ON FIRE BY MANY SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. CONTAIN
SPILL IMMEDIATELY IN SMALLEST POSSIBLE AREA WITH BOOMS, DIKING OR
IMPOUNDING. RECOVER AS MUCH FREE PRODUCT AS POSSIBLE. ADD SAND,
CLAY, DIATOMACEOUS EARTH OR SUITABLE ABSORBENT TO SPILL AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT BEING
USED. DO NOT STORE OR HANDLE NEAR HEAT, SPARKS, FLAME OR STRONG
OXIDANTS. USE AND STORE IN COOL, VENTILATED AREA.
Other Precautions:TO MINIMIZE FIRE OR EXPLOSION RISK FROM STATIC CHARGE
ACCUMULATION AND DISCHARGE, EFFECTIVELY GROUND PRODUCT TRANSFER
SYSTEM. DO NOT TRANSFER PRODUCT TO AN UNLABELED CONTAINER. USE ONLY
AS AVIATION FU EL. DO NOT USE AS CLEANING SOLVENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID PROLONGED BREATHING OF VAPOR. USE
APPROPRIATE NIOSH APPROVED RESPIRATORY PROTECTION WHERE NECESSARY
TO MAINTAIN EXPOSURES BELOW THE TLV'S. USE SUPPLIED AIR RESPIRATORY
PROTECTION IN CONFINED OR ENCLOSED SPACES.
Ventilation:RECOMMENDED. USE EXPLOSION-PROOF EQUIPMENT. NO SMOKING OR
OPEN LIGHT.
Other Protective Equipment:CHEMICAL-RESISTANT APRON OR OTHER IMPERVIOUS
CLOTHING.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
DO NOT WELD, HEAT OR DRILL EMPTY CONTAINER. EMPTIED CONTAINER CAN STILL
RETAIN EXPLOSIVE LIQQUID OR VAPOR AND CAN BE DANGEROUS. REPLACE CAP
OR BUNG. NOT FOR USE AS PROTABLE HEATER OR APPLIANCE FUEL. T OXIC
FUMES MAY ACCUMULATE AND CAUSE DEATH.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:60-518F
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:75 MMHG@68
Vapor Density:3-4
Spec Gravity:.7
pH:7
Viscosity:8CST @-30F
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR LIQUID, HYDROCARBON ODOR
Percent Volatiles by Volume:50 %
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING AGENTS SUCH AS LIQUID CHLORINE,
CONCENTRATED OXYGEN, OR HYPOCHLORITES
Stability Condition to Avoid:HEAT, FLAME, SPARKS, HIGH TEMPERATURES.
FIRE HAZARD IS GREATER AS LIQUID TEMPERATURE RISES ABOVE 85F.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION MAY FORM CARBON
MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:AVOID WASHING, DRAINING, OR DIRECTING MATERIAL
TO STORM OR SANITARY SEWERS AND WATERCOURSES. TREATMENT, STORAGE,
TRANSPORTATION AND DISPOSAL MUST BE IN ACCORDANCE WITH APPLICABLE
FEDERAL, STATE AND LO CAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ACCELERATOR 131
CAGE:69505
CAGE:71410
CAGE:69505
============= Composition/Information on Ingredients =============
Ingred Name:NITROUS ACID, SODIUM SALT; (SODIUM NITRITE) (SARA III)
CAS:7632-00-0
RTECS #:RA1225000
Fraction by Wt: 40%
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SUPP DATA:BETWEEN SOLUTIONS BUT EVAPORATION OF THE MIXTURE
GIVE A RESIDUE WHICH EXPLODES ON HEATING.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL RAT) 85 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: PROLONGED CONTACT MAY DAMAGE THE
EYES. SKIN:CONTACT W/SKIN CAN CAUSE IRRITATION. INGEST:CAN CAUSE
IRRITATION OF MOUTH, THROAT & STOMACH. INGESTION OF LARGE AMOUNTS
CAN CAUSE DEATH.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH IN DIRECTED STREAM OF WATER FOR AT LEAST 15
MINS WHILE FORCIBLY HOLDING EYELIDS APART TO ENSURE COMPLETE
IRRIGATION OF ALL EYE & LID TISS. GET MD. SKIN:WASH THORO W/SOAP &
WATER. IF I RRIT PERSISTS, GET MD. INGEST:DRINK LGEQTYS OF WATER.
INDUCE VOM. GET MD. NEVER GIVE ANYTHING BY MOUTH TO AN UNCON
PERSON. INHAL:REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O2/ARTF
RESP) .
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:AS REQUIRED TO EXTINGUISH SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PRESENTS NO HAZARD IN LIQUID FORM,
HOWEVER CHEMICAL CONTAINS STRONG OXIDIZERS WHICH MAY SUPPLY OXYGEN
WHEN DRY.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE CLOTHING. ABSORB ON NON-
COMBUSTIBLE MATERIAL (VERMICULITE, SAND, EARTH) AND STORE IN
SUITABLE DRUM. FLUSH THE CONTAMINATED AREA W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WE RECOM ALL CHEMS BE STORED & USED IN
LOCATIONS WHICH WILL NOT PERMIT DIRECT ACCESS TO SANITARY/SURF
DRAINS. FOR INDUS USE ONLY. MATL IS TOXIC.
Other Precautions:STORAGE & USE AREAS SHOULD BE CONSTRUCTED IN SUCH A
MANNER THAT ANY CHEMICALS LOST CAN BE EITHER SALVAGED OR SUITABLY
TREATED TO PREVENT POLLUTION. DO NOT TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR, IF MISTING
OCCURS.
Ventilation:USE W/ADEQUATE VENTILATION.
Other Protective Equipment:AS REQUIRED TO AVOID CONTACT. EYE WASH
FACILITY & EMERGENCY SHOWER SHOULD BE IN CLOSE PROXIMITY.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MATLS TO AVOID:ANHYDRIDE, SODIUM AMIDES, SODIUM DISULPHITE & SODIUM
THIOCYANATES. CONT W/STRONG ACIDS WILL CAUSE RELS OF TOX NITROGEN
OXIDE GAS. MAY REACT W/SECONDARY OR TERTIARY AMINES TO PRDCE NITRO
SAMINES (OSHA REGULATES DIMETHYLNITROSAMINE AS A SUSPECT
CARCINOGEN). SODIUM THIOSULFATE:THERE IS NO INTERACTION (ING 2)
================== Physical/Chemical Properties ==================
HCC:D1
Boiling Pt:B.P. Text:>210F,>99C
Spec Gravity:1.25-1.35
Solubility in Water:COMPLETE
Appearance and Odor:SOLUTION IS LIGHT YELLOW LIQUID; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
KEEP SEPARATE FROM ORG MATLS, PAINT THINNERS, REDUCING AGENTS, ACIDS,
AMMONIA SALTS, AMINES, PHTHALIC (SUPP DATA)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NOX.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS CHEMICAL DOES NOT EXHIBIT ANY OF THE
CHARACTERISTICS OF HAZARDOUS WASTE AS DEFINED IN TITLE 40, CODE OF
FEDERAL REGULATIONS, 261.3. CONTACT A LICENSED DISPOSAL AGENT.
DISPOSAL MUST BE IN ACCORDAN CE W/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RTV700
Preparer's Name:D A POLSINELLI
CAGE:01139
CAGE:01139
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGEST/INHAL: NONE KNOWN. SKIN:
MAY CAUSE MILD IRRITATION. EYE: MAY CAUSE MILD IRRITATION. CHRONIC:
NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INGEST: RINSE MOUTH W/WATER SEVERAL TIMES. SKIN: WASH W/SOAP
& WATER. INHAL: NONE KNOWN. REMOVE TO FRESH AIR. SUPPORT BREATHING
(GIVE O2/ARTIFICIAL RESPIRATION) . EYE: IMMEDIATELY FLUSH W/PLENTY
OF WATER FOR AT LEAST 15 MINS & GET MDIF IRRITATION PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>300F,>149C
Extinguishing Media:ALL STANDARD FIREFIGHTING MEDIA.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE, SCRAPE OR SOAK UP IN AN INERT MATERIAL &
PUT IN A CONTAINER FOR DISPOSAL. WASH WALKING SURFACES W/DETERGENT
& WATER TO REDUCE SLIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE KNOWN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCALIZED VENTILATION SHOULD BE USED TO CONTROL DUST
LEVELS.
Other Protective Equipment:NONE KNOWN.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>500F,>260C
Vapor Pres:NEG
Vapor Density:NEG
Spec Gravity:1.07
Evaporation Rate & Reference:NEGLIG (BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:IVORY LIQUID; LOW VARNISH ODOR.
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN. APPLIES IN UNCURED STATE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE &
SILICON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE W/FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SURF-KOTE A-5021
Preparer's Name:SCOTT A. WILSON
CAGE:DO354
CAGE:DO354
CAGE:01094
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <75.0%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MOLYBDENUM DISULFIDE
CAS:1317-33-5
RTECS #:QA4697000
Fraction by Wt: <15.0%
OSHA PEL:10 MG/M3 TDUST (MO)
ACGIH TLV:10 MG/M3 (MO); 8990
Ingred Name:ANTIMONY TRIOXIDE (SARA III)
CAS:1309-64-4
RTECS #:CC5650000
Fraction by Wt: <5.0%
OSHA PEL:0.5 MG/M3 (SB)
ACGIH TLV:0.5 MG SB/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LEAD ORTHO-PHOSPHITE (PBO.PBHPO*3 1/2.H*20)
CAS:1241-20-7
Fraction by Wt: <5.0%
OSHA PEL:0.05MG/CUM
ACGIH TLV:0.15MG/CUM AS PB
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:HEADACHE,DIZZINESS,POSSIBLE
UNCONSCIOUSNESS AND EVEN ASPHYSIATION. CHRONIC:VISUAL
IMPAIRMENT,LUNG,KIDNEY,LIVER,AND SPLEEN DAMAGE.
Effects of Overexposure:IRRITATION,HEADACHE DIZZINESS,COMA.
======================= First Aid Measures =======================
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR; IF BRTHNG
DIFF GIVE OXYGEN. EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP & WATER. RMV CONTAM CLTHG & SHOES. INGEST:DO NOT INDUCE
VOMIT. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:113F/45C
Extinguishing Media:CO*2,DRY CHEMICAL,FOAM
Fire Fighting Procedures:USE SCBA & FULL BODY PROTECTION
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND ARE
FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL, REMOVE HEAT & IGNITION SOURCES,
COLLECT SPILL W/RAGS OR ABSORBENT & PLACE IN CLOSABLE CONTAINER
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA.
Other Precautions:AVOID INGESTION, INHALATION, EYE/SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR FOR ORGANIC VAPORS
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL PROTECTIVE CLOTHING,SAFETY SHOWER,EYE
WASH STATION
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST;WASH AFTER EACH USE.DO NOT EAT,DRINK AND SMOKE IN WORK
AREA.
Supplemental Safety and Health
MSDS RECEIVED BY DGSC-SLM:APRIL 22,1988.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>230F/110C
Vapor Density:>1.0
Spec Gravity:<1.0
Evaporation Rate & Reference:>1.0 (BUT.ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLUE-BLACK LIQUID, SOLVENT ODOR.
Percent Volatiles by Volume:<85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS
Stability Condition to Avoid:EXCESS HEAT & IGNITION SOURCES
Hazardous Decomposition Products:OXIDES OF SULFUR, LEAD, ANTIMONY,
CARBON;ACRID FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IAW ALL LAWS & REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:77200 ALL WEATHER ACRYLIC LATEX CAULK WHITE
CAGE:EO559
CAGE:EO559
CAGE:6R552
============= Composition/Information on Ingredients =============
Ingred Name:VOL ORGANIC CMPD: 0.27 LBS/GAL (32G/L-WATER)
RTECS #:9999999VO
Ingred Name:MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES
MINERAL SPIRITS
CAS:64742-88-7
Fraction by Wt: 1%
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF THE
RESPIRATORY TRACT. EYES/SKIN: IRRITATION. INGESTION: LARGE
QUANTITIES MAY CAUSE DISTRESS OF THE DIGESTIVE TRACT.
PROLONGED/REPEATED BREATHING OF SPRAY/MIST/DUST OVER A PE RIOD OF
YEARS MAY CAUSE DISTRESS OF THELUNGS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NAUSEA, IRRITATION, DIZZINESS, HEADACHE
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/LARGE AMOUNTS
OF WATER FOR 15 MINS. SKIN: REMOVE W/SOAP & WATER. INGESTION: DRINK
1/2 GLASSES OF WATER TO DILUTE. DON'T INDUCE VOMITING. TREAT
SYMPTOMATI CALLY. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:NONE
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT INCLUDING SCBA.
WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE USE WATER TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE IF EXPOSED
TO EXTREME HEAT. AFTER WATER EVAPORATES, REMAINING MATERIAL WILL
NOT BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:WASH W/WATER. CONTAIN & REMOVE W/INERT
ABSORBENT. STORE IN CLOSED CONTAINER UNTIL PROPERLY DISPOSED OF.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <110F & KEEP FROM FREEZING. KEEP
CONTAINER CLOSED WHEN NOT IN USE. DON'T REUSE EMPTY CONTAINERS.
KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DON'T BREATHE VAPORS, SPRAY MIST/SANDING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OUTDOOR/OPEN AREAS W/UNRESTRICTED
VENTILATION/SANDING/GRINDING OPERATIONS: NIOSH/MSHA APPROVED
MECHANICAL FILTER RESPIRATOR. RESTRICTED AREA: NIOSH/MSHA APPROVED
CHEMICAL/MECHANIAL FILTERS. (SEE SUPP)
Ventilation:USE ONLY W/ADEQUATE VENTILATION. PROVIDE GENERAL
DILUTION/LOCAL EXHAUST TO KEEP AIR CONTAMINATION BELOW LIMIT.
Other Protective Equipment:NOT REQUIRED
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
VAPOR PRESSURE IS FOR MINERAL SPIRITS. VENTILATION CONT'D: CONFINED
AREA: NIOSH/MSHA APPROVED AIR SUPPLY RESPIRATORS/HOODS. EYE
PROTECTION CONT'D: SAFETY GLASSES W/SIDESHIELDS. USE NIOSH/MSHA
APPROVED RESPIRATORS WHEN FLAME CUTTING, WELDING, BRAZING &
SANDING MATERIAL C
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-390F
Vapor Pres:2 (SUPP)
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:COMPLETE
Appearance and Odor:MILD CHARACTERISTIC ODOR
Percent Volatiles by Volume:29
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MATERIALS INCOMPATIBLE W/WATER.
Stability Condition to Avoid:FREEZING
Hazardous Decomposition Products:CO, CO2, OXIDES OF METALS
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE ONLY IN APPROVED FACILITY. DON'T
INCINERATE CLOSED CONTAINERS. DISPOSE OF IAW/LOCAL, STATE & FEDERAL
REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:ULTRA
CAGE:53798
CAGE:53798
============= Composition/Information on Ingredients =============
Ingred Name:2-PYRROLIDINONE, 1-METHYL-; (N-METHYL-2-PYROLIDONE)
CAS:872-50-4
RTECS #:UY5790000
Fraction by Wt: <1%
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:AMMONIA (SARA III)
CAS:7664-41-7
RTECS #:BO0875000
Fraction by Wt: <1%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM/35 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:POLYURETHANE; (WATER DISPERSABLE)
Fraction by Wt: <5%
Ingred Name:ETHANOL, 2-(2-METHOXYETHOXY)-; (DIETHYLENE GLYCOL
MONOMETHYL ETHER)
CAS:111-77-3
RTECS #:KL6125000
Fraction by Wt: <5%
Ingred Name:FORMALDEHYDE
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: <0.05%
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM; A2; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ETHANOL, 2-BUTOXY-, PHOSPHATE (3:1); (TRIBUTOXYETHYL
PHOSPHATE)
CAS:78-51-3
RTECS #:KJ9800000
Fraction by Wt: <2%
ACGIH TLV:0.5 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DIRECT EYE CONTACT CAUSES IRRITATION.
MAY BE HARMFUL IF SWALLOWED. CHRONIC: FORMALDEHYDE IS A SUSPECTED
HUMAN CARCINOGEN. TRIBUTOXYETHYL PHOSPHATE IS A SUSPECT NEUROTOXIN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PERSONS WITH CERTAIN NEUROLOGICAL
DISORDERS SUCH AS MULTIPLE SCLEROSIS SHOULD CONSULT PHYSICIAN PRIOR
TO EXPOSURE.
======================= First Aid Measures =======================
First Aid:INGESTION: CONTACT PHYSICIAN OR POISON CONTROL CENTER
IMMEDIATELY. INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH
IMMEDIATELY WITH PLENTY OF COOL WATER FOR AT LEAST 15 MINUTES. IF
IRRITATION PERSISTS, C ONTACT PHYSICIAN. SKIN: WASH WITH SOAP AND
WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:220F,104C
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS
.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:BLOCK OFF SPILL. VACUUM UP EXCESS. FLUSH
RESIDUES WITH PLENTY OF WATER. DO NOT RETURN CONTAMINATED FINISH TO
DRUM OF PRODUCT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT TEMPERATURES >32F. KEEP IN
CONTAINERS CLOSED WHEN NOT IN USE. DO NOT CONTAMINATE PRODUCT BY
RETURNING UNUSED FINISH FROM MOP BACK INTO DRUM.
Other Precautions:USE ONLY CLEAN MOPS WHEN APPLYING TO FLOOR. DO NOT
REUSE EMPTY CNTNRS FOR ANY PURPOSE. DESTROY EMPTY DRUMS BY
CRUSHING/PUNCTURING TO PVNT REUSE. READ & FOLLOW ALL LBL DIRECTIONS
& PRECS BEFORE USING P ROD. PRODS ARE INTENDED FOR (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED. WHERE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:TYPICAL ROOM VENTILATION.
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PERCENT VOLATILES: 75-85 (WT). OTHER PRECAUTIONS: INDUSTRIAL AND
INSTITUTIONAL USE ONLY. NOT INTENDED FOR HOUSEHOLD USE OR RESALE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.036 (H*2O=1)
pH:9.5
Solubility in Water:EMULSION
Appearance and Odor:WHITE EMULSION WITH FAINT AMMONIA ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT MIX WITH ANY OTHER CHEMICALS.
Stability Condition to Avoid:TEMPERATURES BELOW 32F.
Hazardous Decomposition Products:NONE EXPECTED.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS IS NOT HAZARDOUS WASTE. LARGE AMOUNTS OF
FINISH THAT CANNOT BE USED SHOULD BE GIVEN TO WASTE DISPOSAL
COMPANY. FOLLOW ALL FEDERAL, STATE AND LOCAL REGULATIONS REGARDING
WASTE DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CELITE 535
Preparer's Name:RICHARD A. VERSEN
CAGE:8V867
CAGE:8V867
============= Composition/Information on Ingredients =============
Ingred Name:FLUX CALCINED DIATOMACEOUS EARTH
CAS:68855-54-9
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (RESP)
ACGIH TLV:10 MG/M3 (NUISSANCE)
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: <60%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV=.05MG/M3 CRISTOBALITE
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT CONTAINS CRYSTALLINE
SILICA,A HAZARD BY INHALATION.INHAL:POSSIBLY
CARCINOGENIC,IRRITATING.EYES:IRRITANT.
Explanation of Carcinogenicity:CRYSTALLINE SILICA IS RATED AS A 2B
CARCINOGEN BY IARC.
Effects of Overexposure:INHAL:SORE THROAT AND NOSE,POSSIBLE
CONGESTION.EYES:TEMPORARY MECHANICAL IRRITATION OR REDNESS.
Medical Cond Aggravated by Exposure:PREEXISTING UPPER RESPIRATORY
DISEASES(EG.BRONCHITIS,EMPHYSEMA,ASTHMA).
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR;DRINK WATER,BLOW NOSE TO EVACUATE
DUST.EYES:FLUSH WITH WATER.IF IRRITATION PERSISTS,CALL
PHYSICIAN.SKIN:NONE NEEDED.INGEST:NONE NEEDED.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE APPROPRIATE MEDIA FOR SURROUNDING FIRE.
Fire Fighting Procedures:HMIS SUGGESTS TO USE A SELF-CONTAINED
BREATHING APPARATUS WHENEVER FIGHTING A CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:MANUFACTURER STATES NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SHOVEL OR SWEEP UP WITH THE AID OF A DUST
SUPPRESSANT(EG.WATER),VACUUM THE REMAINING PARTICLES.PLACE IN AN
APPROPRIATE CONTAINER FOR DISPOSAL.UNCONTAMINATED MATERIEL MAY BE
REUSED.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CREATING DUST.MAINTAIN GOOD
HOUSEKEEPING PRACTICES.REPAIR BROKEN BAGS IMMEDIATELY.
Other Precautions:USE PROPER RESPIRATORY PROTECTION WHEN REPAIRING
CONTAMINATED EQUIPMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH RESPIRATOR AS FOLLOWS:<10XPEL-HALF
MASK,<100XPELFULL FACE RESPIRATOR,<200XPEL-TYPE C AIR SUPPLIED
CONTINOUS FLOW RESPIRATOR.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:NONE
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
THIS NSN IS A FORMULA CHANGE FROM THE SAME NSN,CAGE 75165.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Spec Gravity:2.3
Solubility in Water:NEGLIGIBLE
Appearance and Odor:POWDER,FINE;WHITE;NO ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HMIS SUGGESTS HYDROFLUORIC ACID.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS ITEM IS CONSIDERED NON-HAZARDOUS BY
RCRA(OSHA 40CFR PART 261).DISPOSE OF IN A LANDFILL IN ACCORDANCE
WITH FEDERAL,STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:B77 G 500 BASE C WEATHER PERFECT HOUSE & TRIM SATIN
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ZINC OXIDE *95-4*
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 0-1%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM FUME
Ingred Name:ZINC COMPOUND
Fraction by Wt: 1.5%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 49.8-59%
Ingred Name:ETHYLENE GLYCOL, GLYCOL
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
Other REC Limits:10 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON DIOXIDE, CRYSTALLINE QUARTZ, SAND (ANIMAL CARC,
SUSPECTED HUMAN CARC IARC-GROUP 2A; SUSPECTED CARC NTP) *95-4*
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0-3%
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:0.1 MG/CUM RESP DUST
ACGIH TLV:0.1 MG/CUM RESP DUST
Ingred Name:SILICA CRYSTALLINE, SILICA (CRISTOBALITE) (SUSPECTED HUMAN
CARCINOGEN BY IARC, SUSP CARC BY NTP; IARC GROUP 2A) *95-4*
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: 1%
Other REC Limits:0.05 MG/CUM NIOSH
ACGIH TLV:0.05 MG/CUM
Ingred Name:CLAY (KAOLIN), ALUMINUM SILICATE
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 0-5%
ACGIH TLV:10 MG/CUM TOTAL DUST
Ingred Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN, IARC
GROUP 3) *95-4*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-19%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN & UPPER
RESPIRATORY SYSTEM. CRYSTALLINE SILICA-LONG TERM EXPOSURE TO HIGH
LEVELS OF SILICA DUST MAY CAUSE LUNG DAMAGE (SILICOSIS). PROLONGED
OVEREXPOSURE TO SOLVENTS MAY CAUSEADVERSE EFFECTS TO THE LIVER,
URINARY SYSTEMS.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, HEADACHE, NAUSEA, DIZZINESS,
REDNESS, ITCHING, BURNING SENSATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/LARGE AMOUNTS OF
WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL, ALCOHOL FOAM
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. USE WATER TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE & REMOVE
W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE & APPROPRIATE
LABELING. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. USE ONLY W/ADEQUATE
VENTILATION. AVOID BREATHING VAPOR & SPRAY MIST. AVOID CONTACT
W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CAN'T BE CONTROLLED BELOW
TLV BY VENTILATION, USE A NIOSH/MSHA APPROVED PROPERLY FITTED
ORGANIC VAPOR/PARTICULATE RESPIRATOR. WHEN SANDING/ABRADING FILM,
USE A NIOSH/MSHA APPROVED DUST/MIST RESPIRATOR.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL EXHAUST: ACCEPTABLE IF
THE EXPOSURE IS KEPT < APPLICABLE EXPOSURE LIMITS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING.
Supplemental Safety and Health
PH: 8.5-9.8.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-448F
Vapor Density:>1
Spec Gravity:1.1-1.3
pH:(SUPP)
VOC Grams/Liter:.93
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:40-75
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT & OTHER IGNITION SOURCES
Hazardous Decomposition Products:BY FIRE: CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DON'T
INCINERATE CLOSED CONTAINER. DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SOLUTION S0121 HTD-1 (BUFFER)
Preparer's Name:RICKY A. STACKHOUSE
CAGE:89524
CAGE:89524
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-AMINO-; (MONOETHANOLAMINE). LD50:(ORAL,RAT)
2,100 MG/KG.
CAS:141-43-5
RTECS #:KJ5775000
Fraction by Wt: 10-20%
OSHA PEL:3 PPM;6 PPM STEL
ACGIH TLV:3 PPM;6 PPM STEL
Ingred Name:FIRST AID:CTL SYMPS & CLINICAL CNDTN. CAUTION:IF UNCON,
HAVING TROUBLE BRTHG/IN CONVLS, DO NOT INDUCE VOMIT/GIVE WATER.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:DISP TO SANITARY LANDFILL. CAN BE INCIN
I/A/W LOC, STATE & FED REGS. EMPTY PROD CNTNR SHLD BE (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:PUNCTURED, IF PLASTIC & PLACED IN GARBAGE COLLECTION
CONTAINER.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYE CONTACT:CAN CAUSE MODERATE TO
SEVERE IRRITATION. INGESTION:CAN BE HARMFUL. INHALATION:CAN CAUSE
RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:A REVIEW OF AVAILABLE DATA DOES NOT IDENTIFY
ANY SYMPTOMS FROM EXPOSURE.
Medical Cond Aggravated by Exposure:A REVIEW OF AVAILABLE DATA DOES NOT
IDENTIFY ANY WORSENING OF EXISTING CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH FOR AT LST 15 MINS WHILE HOLDING EYELIDS
OPEN. CALL MD AT ONCE. SKIN:IMMED FLUSH W/WATER FOR AT LST 15 MINS.
FOR LG SPLASH, FLOOD BODY UNDER SHOWER. CALL MD AT ONCE. INGEST:DO
NOT IND UCE VOMIT. GIVE WATER. CALL MD. INHAL:REMOVE TO FRESH AIR.
TREAT SYMPS. CALL MD. NOTE TO MD:NO SPECIFIC ANTIDOTE IS KNOWN.
BASED ON INDIVIDUAL RXNS OF PATIENT, MD'S JUDGMENT SHLD BE USED TO
(ING 2)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:PROD WOULD NOT BE EXPECTED TO BURN UNLESS ALL WATER
IS BOILED AWAY. REMAINING ORGS MAY BE IGNITABLE. USE WATER (SUPDAT)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY EVOLVE NO*X UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:SM LIQ SPILLS:CONTAIN W/ABSORB MATL, SUCH AS
CLAY, SOIL/ANY COMMERCIALLY AVAIL ABSORB. SCOOP RECLAIMED LIQ &
ABSORB INTO RECOVERY/SALVAGE DRUMS FOR DISP. CERCLA, 40 CFR 117,
302:NOTIFICATION OF SPILLSOF THIS PRODUCT IS NOT REQUIRED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MAY BE IRRITATING TO EYES, NOSE &
SKIN. KEEP CONTAINER TIGHTLY CLOSED. DO NOT TAKE INTERNALLY.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . RESPIRATORY PROTECTION IS NOT NORMALLY
NEEDED.
Ventilation:GENERAL VENTILATION IS RECOMMENDED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:IF CLOTHING IS CONTAMINATED, REMOVE CLOTHING &
THORO WASH AFFECTED AREA. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
PH:(NEAT)10. EXTING MEDIA:TO COOL CNTNRS EXPOSED TO FIRE. MATLS TO
AVOID:NITROUS ACID, ORG/INORG NITRITES/ATMS W/HIGH NITROUS OXIDE
CONCS. AVOID CONT W/STRONG OXIDIZERS (E.G., CHLORINE, PEROXIDES,
CHR OMATES, NITRIC ACID, PERCHLORATES, CONCOXYGEN, PERMANGANATES)
WHICH CAN GEN HEAT, FIRES, EXPLOS & RELS OF TOX FUMES.
================== Physical/Chemical Properties ==================
pH:SUPDAT
Solubility in Water:COMPLETELY
Appearance and Odor:COLORLESS LIQUID; SLIGHT AMINE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
N-NITROSAMINES, MANY ARE CANCER CAUSING AGENTS TO LAB ANIMALS, MAY BE
FORMED WHEN CERTAIN AMINES ARE MIXED W/ (SUPDAT)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:IN EVENT OF COMBUSTION CO, CO*2, NO*X
MAY BE FORMED. DO NOT BREATHE SMOKE/FUMES. WEAR SUITABLE PROTECTIVE
EQUIPMENT.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF PROD BECOMES WASTE, IT DOES NOT MEET CRITERIA
OF HAZ WASTE AS DEFINED UNDER RCRA 40 CFR 261, SINCE IT DOES NOT
HAVE CHARACTS OF SUBPART C,(I.E. D001-D017) NOR IS IT LISTED UNDER
SUBPART D. AS NON-H AZ LIQ WASTE, IT SHLD BE SOLIDIFIED BEFORE (ING
3)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:557 VI-AC YELLOW
CAGE:0FWX8
CAGE:0FWX8
============= Composition/Information on Ingredients =============
Ingred Name:2-((HYDROXYMETHYL)AMINO)-2-METHYLPROPANOL
CAS:52299-20-4
RTECS #:UB6471000
Fraction by Wt: <1%
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
Other REC Limits:10 MG/CUM
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PROPANOIC ACID, 2-METHYL, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL, TEXANOL
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: <5%
Ingred Name:CHLOROPARAFFIN
Fraction by Wt: 5-10%
Ingred Name:HYDROXYPROPYL METHYCELLULOSE
CAS:9004-65-3
RTECS #:NF9125000
Fraction by Wt: 0.33%
Ingred Name:SODIUM POLYACRYLATE
CAS:9003-04-7
RTECS #:WD6826000
Fraction by Wt: 0.12%
Ingred Name:NONIONIC SURFACTANT
Fraction by Wt: 0.54%
Ingred Name:SODIUM SALT OF POLYCARBOXYLIC ACID
Fraction by Wt: 0.41%
Ingred Name:DEFOAMER
Fraction by Wt: 0.77%
Ingred Name:POT TRIPOLY PHOSPHAT
Fraction by Wt: 0.54%
Ingred Name:METAL OXIDE
Fraction by Wt: 2.31%
Ingred Name:ALUMINUM POTASSIUM SILICATES
Fraction by Wt: 2.52%
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 16%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192
Ingred Name:VEGETABLE PHOSPHTIDES
Fraction by Wt: 1.12%
Ingred Name:POLYETHYLENE, POLYETHYLENE RESIN (HOMOPOLYMER)
CAS:9002-88-4
RTECS #:TQ3325000
Fraction by Wt: 1.93%
Ingred Name:ETHYLENE-VINYL ACETATE COPOLYMER
(ACETIC ACID ETHENYL ESTER, POLYMER W/ETHENE)
CAS:24937-78-8
Fraction by Wt: 50.84%
Ingred Name:WALLASTONITE
Fraction by Wt: 3.87%
Ingred Name:MAGNESIUM ALUMINUM SILICATE
CAS:1327-43-1
RTECS #:VV8880000
Fraction by Wt: 4.14%
Ingred Name:WATER, H2O
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 87%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, REDNESS, TEARING, &
BLURRED VISION. SKIN: IRRITATION, DEFATTING, & DERMATITIS.
INHALATION: NASAL & RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS,
FATIGUE, NAUSEA, HEADACHE, UNCONSCIOUS NESS, & ASPHYXIATION.
INGESTION: GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, DIARRHEA,
CHEMICAL PNEUMONITIS, & FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION, REDNESS, TEARING, & BLURRED
VISION. SKIN: IRRITATION, DEFATTING, & DERMATITIS. INHALATION:
NASAL & RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, UNCONSCIOUS NESS, & ASPHYXIATION. INGESTION:
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, DIARRHEA, CHEMICAL
PNEUMONITIS, & FATAL.
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/PLENTY OF
WATER. INGESTION: GIVE 2 GLASSES OF WATER. INDUCE VOMITING. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. ASPIRATION OF
MATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN
BE FATAL. INHALATION: REMOVE TO FRESH AIR. GIVE CPR OR OXYGEN IF
NEEDED. KEEP WARM & QUIET. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>210F
Lower Limits:0.6%
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS W/FULL
FACEPIECE OPERATED IN PRESSURE DEMAND OR OTHER POSITIVE PRESSURE
MODE. WATER SPRAY MAY BE INEFFECTIVE.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: SCOOP UP INTO SUITABLE CONTAINERS. MOP
UP W/RAGS, FLUSH W/WATER. LARGE: EVACUATE AREA. WEAR PROTECTIVE
EQUIP. STOP SPILL AT SOURCE. DIKE AREA TO PREVENT SPREADING. PUMP
LIQUID TO SALVAGE TANK. PLACE THE REMAINDER INTO CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE IN HIGH TEMPERATURES, NEAR
OPEN FLAME OR SUN, HEAT, & SPARKS. DON'T WELD OR FLAME CUT AN EMPTY
DRUM. GROUND/BOND DRUMS WHEN POURING.
Other Precautions:AVOID BREATHING SANDING DUST & CONTACT W/SKIN. KEEP
CONTAINERS TIGHTLY CLOSED & UPRIGHT TO PREVENT LEAKAGE. CONTAINERS
MAY BE HAZARDOUS WHEN EMPTIED. SINCE EMPTY CONTAINERS RETAIN
PRODUCT RESIDUES, OB SERVE ALL HAZARD PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL)/LOCAL EXHAUST
VENTILATION TO KEEP <TLV.
Other Protective Equipment:IMPERVIOUS CLOTHING, BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING/USING WASHROOM. SMOKE IN SMOKING
AREAS ONLY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:210-471F
Vapor Pres:1
Vapor Density:<AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:41-45%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES OR EXTREME HEAT, OPEN
FLAME, OR SPARKS.
Hazardous Decomposition Products:CO2, CO, & VARIOUS HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. PREVENT RUN-OFF TO SEWERS, STREAMS OR OTHER
BODIES OF WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:386-392 ROTARY
Preparer's Name:DICK KARBO
CAGE:KMADD
CAGE:KMADD
============= Composition/Information on Ingredients =============
Ingred Name:COPPER COMPOUND
Fraction by Wt: 1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT W/SKIN/EYES CAN
CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/WATER. SKIN: WASH AFFECTED AREA
W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WIPE UP & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS. LARGE: SCOOP MATERIAL INTO SEALABLE
CONTAINERS. WIPE UP REMAINDER & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:WASH AFTER USE. REMOVE/LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. DON'T CONSUME FOOD/BEVERAGE WHERE PRODUCT IS
USED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:470-610F
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:INSOLUBLE
Appearance and Odor:OILY
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: CITRATE BUFFER, 7453
Cage: HO495
Box: 329
=======================================================
Contractor Summary
=======================================================
Cage: HO495
Box: 329
Cage: 34807
Box: 329
=======================================================
Ingredients
=======================================================
Cas: 1310-73-2
RTECS #: WB4900000
% Wt: 3
OSHA PEL: 2 MG/M3
ACGIH TLV: 2 MG/M3, C
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 6132-04-3
% Wt: 25
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 6381-59-5
% Wt: 15
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: IRRITATING TO EYES, NOSE & SKIN.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
First Aid: INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP)
(FP N). EYES:FLUSH THOROUGHLY W/WATER FOR AT LEAST 15 MINUTES. CONSULT MD.
SKIN:FLUSH W/WATER. REMOVE AFFECTED CLOTHING. WASH SKIN W/S OAP & WATER.
INGEST:GIVE PLENTY OF WATER. DO NOT INDUCE VOMITING. CONSULT MD.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NEUTRALIZE CAREFULLY W/6M HCL & FLUSH DOWN DRAIN
W/EXCESS WATER.
Neutralizing Agent: 6M HCL.
Waste Disposal Methods: NEUTRALIZE & FLUSH DOWN DRAIN W/EXCESS WATER.
DISPOSE ACCORDING TO FEDERAL, STATE & LOCAL REGULATIONS.
Handling And Storage Precautions: AVOID CONTACT W/SKIN OR CLOTHING.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: MEDIA SUITABLE FOR SURROUNDING FIRE (FP N). NOT A FIRE
HAZARD.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: NORMAL VENTILATION.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N). LAB COAT.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
PH: 12
Solubility in Water: SOLUBLE
Appearance and Odor: CLEAR, COLORLESS LIQUID; NO ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: CITRATE BUFFER, 7453
Cage: HO495
Assigned IND: Y
Company Name: LAMOTTE CO
Street: UNKNOWN
PO Box: 329
Zipcode: 21620
Label Required IND: Y
Date Of Label Review: 02/28/1995
Status Code: C
Label Date: 02/28/1995
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:IRRITATING TO EYES, NOSE & SKIN. CHRONIC:NONE
LISTED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RESIN BONDED SILICON CARBIDE ABRASIVE (SUPP
CAGE:21995
CAGE:21995
============= Composition/Information on Ingredients =============
Ingred Name:RESIN;(CURED RESIN)
Fraction by Wt: >4%
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:CRESOL, ALL ISOMERS (CRESYLIC ACID) (SARA III)
CAS:1319-77-3
RTECS #:GO5950000
Fraction by Wt: <0.5%
OSHA PEL:5 PPM,S
ACGIH TLV:5 PPM,S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MAY CONTAIN 1 OR MORE OF INGREDIENTS 5-16
RTECS #:9999999ZZ
Ingred Name:GRAPHITE, NATURAL;(GRAPHITE)
CAS:7782-42-5
RTECS #:MD9659600
Fraction by Wt: >1%
OSHA PEL:15 MPPCF RDUST
ACGIH TLV:2 MG/M3 RDUST; 9293
Ingred Name:SULFUR
CAS:7704-34-9
RTECS #:WS4250000
Fraction by Wt: >1%
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:SARAN (MFR CAS # 75-35-5)
CAS:8013-77-2
RTECS #:VQ2000000
Fraction by Wt: +1%
ACGIH TLV:20 MG/M3 (MFR)
Ingred Name:ALUMINUM;(ALUMINUM POWDER) (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: >1%
OSHA PEL:15MG/M3 TDUST;5 FUME
ACGIH TLV:10 MG/M3 DUST;5 FUME
Ingred Name:COPPER;(COPPER POWDER) (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: >1%
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2MG/M3 FUME;1 DUST
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BARIUM SULFATE;(BARYTES)
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: >1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SODIUM FLUOALUMINATE;(CRYOLITE)
CAS:15096-52-3
RTECS #:WA9625000
Fraction by Wt: >1%
OSHA PEL:2.5 MG/M3 AS F
ACGIH TLV:2.5 MG/M3 AS F
Ingred Name:PYRITE (FES)
Fraction by Wt: >1%
ACGIH TLV:2 MG/M3 (MFR)
Ingred Name:CALCIUM OXIDE; (LIME)
CAS:1305-78-8
RTECS #:EW3100000
Fraction by Wt: >1%
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:CALCIUM SILICATE;(WOLLASTONITE)
CAS:1344-95-2
RTECS #:VV9150000
Fraction by Wt: >1%
OSHA PEL:15MG/M3 TDUST;5RDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:GLASS FABRIC;(GLASS MESH)
Fraction by Wt: >1%
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:ISOPRENE;(DPR RUBBER) (SARA III)
CAS:78-79-5
RTECS #:NT4037000
Fraction by Wt: >1%
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SILICON CARBIDE
CAS:409-21-2
RTECS #:VW0450000
Fraction by Wt: >50%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:GRINDING WHEEL DUST IS CLASSIFIED
UNDER OSHA AS INERT OR NUISANCE DUST AND WOULD HAVE THE PULMONARY
EFFECTS OF INERT DUST. RESIN COATED GLASS FABRIC IS USED IN SOME
PRODUCTS AS REINFORCEMENT.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O2/ARTF
RESP) . EYE:FLUSH WITH POTABLE WATER FOR A MINIMUM OF 15 MINUTES.
CALL MD . SKIN:FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL MD (FP N
). INGEST:CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA AND COLLECT MATERIAL IN MOST
CONVENIENT AND SAFE MANNER FOR RECLAMATION OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY AREA. TAKE MEASURES TO
INSURE AGAINST MECHANICAL DAMAGE.
Other Precautions:STORE IN ACCORDANCE WITH ANSI B7.1. NIOSH/MSHA
APPROVED RESPIRATORY PROTECTION MAY BE REQUIRED IN AN EXTREMELY
DUSTY ENVIRONMENT. REFER TO ANSI Z43.1 FOR ADDITIONAL
RECOMMENDATIONS. USE ACCORDING TO I NSTRUCTIONS PACKED WITH THE
WHEELS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUST RESPIRATORS MAY BE
REQUIRED.
Ventilation:UTILIZE LOCAL EXHAUST TO KEEP DUST BELOW TLV.
Other Protective Equipment:IF APPLICABLE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR PT#/TRADE NAME:PRODUCTS SR, SCR, SFR, CHS, RFC, SC ABRASIVE WHEELS.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:VARIES (H2O=1)
Solubility in Water:NOT SOLUBLE
Appearance and Odor:SOLID, VARIOUS GRAY AND BROWN COLORS, ODORLESS
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:UNKNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A SECURED SANITARY LANDFILL AND IN
ACCORDANCE WITH FEDERAL, STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ZYGLO PENETRANT ZL-27A
Preparer's Name:BRUCE C. GRAHAM, CH. CHEM
CAGE:37676
CAGE:37676
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, WHITE (PETROLEUM)
CAS:8042-47-5
RTECS #:PY8047000
Fraction by Wt: 30-60%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:ISODECYL DIPHENYL PHOSPHATE
CAS:29761-21-5
Fraction by Wt: 30-60%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISOBUTANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 30%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAN IRRITATE SKIN BY REMOVING NATURAL
SKIN OILS ON LONG OR REPEATED EXPOSURES. MAY CAUSE EYE IRRITATION.
WHEN HEATED OR SPRAYED, ZL-27A VAPORS CAN CAUSE DIZZINESS AND
NAUSEA. NOT SIGNIFIGANT IF SWALLO WED IN SMALL MOUTHFULS.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:INHALATION-POSSIBLE DIZZINESS, NAUSEA.
EYES-IRRITATION. SKIN-IRRITATION. INGESTED-NONE STATED.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT,
GIVE OXYGEN; SKIN:REMOVE CONTAMINATED CLOTHES. WASH OFF WITH
FLOWING WATER. USE SOOTHING LOTION. IF IRRITATION PERSISTS, GET
MEDICAL ATTN; E YES: IMMEDIATELY RINSE/FLUSH WITH COPIOUS AMOUNT OF
RUNNING WATER, AND GET MEDICAL ATTENTION. INGESTION: GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY. DO NOT
SPRAY ON BURNING PRODUCT.
Unusual Fire/Explosion Hazard:WHEN INVOLVE IN COMBUSTION, MAY EMIT
TOXIC GASES AT OR ABOVE DECOMPOSITION TEMPERATURE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.SMALL SPILL:WIPE UP OR
MOP UP BUT DO NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUMS; LARGE
SPILL:WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA FAR AHEAD.ABSORB
LIQUID WITH COMMERCIA L ABSORBENT.TRANSFER WASTE MATL IN SALVAGE
TANKS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA. AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS. KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS. DO NOT SMOKE WHILE USING. DO
NOT HEAT ABOVE 130F(54C). AVOID FREQUENT OR PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A RESPIRATOR WITH CHEMICAL CARTRIDGE. IN
CONFINED AREAS, WEAR A FULL MASK WITH SEPARATE AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW 350PPM LIMIT.
Other Protective Equipment:EITHER USE IN A SPRAY BOOTH OR NEXT TO AN
EXHAUST VENT.
Work Hygienic Practices:AVOID SKIN CONTACT. WASH THOROUGHLY AFTER
HANDLING OR USE. LAUNDER CONTAMINATED CLOTTHES.
Supplemental Safety and Health
THIS REPRESENTS NEW FORMULATION OF ZL-27A; OLD FORMULATION DATA UNDER
PNI "B",THIS NSN; THE ZL-27A PENETRANT IS A QUALIFIED PRODUCT OF
QPL-25135-15 FOR TYPE I,METH D,LVL 3 OF MIL-I-25135E, FOR THE NSN
;PER QPL-25135-15, SET CONSISTS OF ZL-27A & ZR-10B, ORZL-22D &
ZR-10A FOR TYPE I, METH D, LEVEL 3 OF THE SPEC; KEY1=N1.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:455F,235C
Vapor Pres:<0.1
Vapor Density:>1
Spec Gravity:0.96
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREEN OILY LIQUID. MILD ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MFR STATED "NONE".
Stability Condition to Avoid:HEAT, HIGH TEMPERATURES.
Hazardous Decomposition Products:EMITS OXIDES OF CARBON AND NITROGEN ON
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE I/A/W ALL APPLICABLE
FEDERAL, STATE, LOCAL REGULATIONS; IF LOCAL AUTHORITIES PROHIBIT
DUMPING RINSINGS DOWN THE SEWER, PURIFY RINSINGS WITH MAGNAFLUX
WASTE WATER TREATMENT SYSTEM .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-P-53022B TY II CATALYST, 04489CEH, PART B
Kit Part:Y
Preparer's Name:JANE FREEMAN
CAGE:09225
CAGE:09225
============= Composition/Information on Ingredients =============
Ingred Name:1-METHOXY-2-PROPANOL (SOLVENT)
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 45.016%
Other REC Limits:STEL: 150 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:EPOXY RESIN
Fraction by Wt: 30-40%
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 2.333%
Other REC Limits:STEL: 75 PPM
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1,2,4-TRIMETHYLBENZENE (SOLVENT) (SARA III)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 4.468%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:AROMATIC HYDROCARBON (MIXTURE OF C8'S TO C10'S)
CAS:64742-95-6
Fraction by Wt: 8.797%
Other REC Limits:MFR'S LIMIT: 100 PPM
Ingred Name:VOC: 4.991 LBS/GAL 598.071 GRAMS/LITER
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: ANESTHETIC. IRRITANT.
RESPIRATORY TRACT/MUCOUS MEMBRANE IRRITATION
(HEADACHE,NAUSEA,DIZZINESS). SKIN/EYE: CORROSIVE. MAY CAUSE SKIN &
EYE BURNS. INGESTION: MUCOSAL DAMAGE. CHRONIC: REPORTS ASSOCIATED
REPEATED/PROLONGED OVEREXPOSURE W/PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE, LIVER & KIDNEY DAMAGE.
Medical Cond Aggravated by Exposure:ASTHMA AND OTHER RESPIRATORY
AILMENTS; CHEMICAL SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM & QUIET. NOTIFY A PHYSICIAN. EYES: FLUSH IMMEDIATELY WITH
LARGE AMOUNTS OF RUNNING WATER FOR AT LEAST 15 MINUTES. TAKE TO A
PHYSICIAN FOR MEDICAL TREATMENT. SKIN: WASH AFFECTEDAREAS WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. CONSULT A PHYSICIAN.
INGESTION: CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:60.0F,15.6C
Lower Limits:0.9
Upper Limits:36.5
Extinguishing Media:FOAM, DRY CHEMICAL, CO2
Fire Fighting Procedures:FULL PROTECT EQUIP W/SCBA.WATER SPRAY MAY BE
INEFFECTIVE,USE TO COOL (FOG NOZZLES PREFERED) CLOSED CONTAINER TO
PREVENT PRESSURE BLDUP,AUTOIGNITION OR EXPLOSION
Unusual Fire/Explosion Hazard:KEEP CONTAINER CLOSED.KEEP FROM
HEAT/IGNIT SOURCE.CLSD CNTNR MAY EXPLODE W/HEAT.DON'T APPLY TO HOT
SURFACES.NEVER USE WELD/CUT TORCH ON/NEAR DRUM (EVEN EMPTY).
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES AND ELECTRICAL, STATIC OR FRICTIONAL SPARKS). AVOID
BREATHING VAPORS. VENTILATE AREA. CONTAIN AND REMOVE WITH INERT
ABSORBENT AND NONSPARKING TOOLS .
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED TO COMPLY WITH OSHA 1910.106. KEEP
AWAY FROM SPARKS AND OPEN FLAME.
Other Precautions:DON'T INGEST. GROUND CONTAINERS WHEN POURING. AVOID
FREE FALL OF LIQUID IN EXCESS OF A FEW INCHES. USE WITH ADEQUATE
VENTILATION & RESPIRATORY EQUIP. AVOID PROLONGED BREATHING OF VAPOR
OR SPRAY MIST. AVOID PROLONGED/REPEATED SKIN CONTACT. *
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OPEN AREA DURING SAND/GRINDING,USE NIOSH MECHAN
FILTER RESPRTR.RESTRICTED VENT,WEAR NIOSH CHEM/MECHAN FILTER
RESPRTR.CONFINED AREA,WEAR NIOSH AIR SUPPLIED RESPRTR/HOOD. USE
NIOSH RESPRTR WHEN FLAME CU TTING,WELDING,HAZING MAT'L COATED
W/PROD
Ventilation:PROVIDE GENERAL DILUTION OR LOCAL EXHAUST VENT TO KEEP AIR
CONTAMINANT CONCENTRATION BELOW PEL & REMOVE DECOMP PRODUCTS
Other Protective Equipment:USE PROTECTIVE SKIN CREAM WHERE CONTACT IS
LIKELY. PREVENT PROLONGED SKIN CONTACT WITH CONTAMINATED CLOTHING.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE. WASH
HANDS BEFORE EATING OR SMOKING. SMOKE IN DESIGNATED AREAS ONLY.
Supplemental Safety and Health
* OTHER PRECAUTIONS CONT'D: EMPTIED CONTAINERS MAY RETAIN HAZARDOUS
RESIDUE OR EXPLOSIVE VAPORS. FOLLOW ALL HAZARDS PRECAUTIONS IN THIS
DATA SHEET UNTIL CONTAINER IS THOROUGHLY CLEANED OR DESTROYED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:232 TO 418F
Decomp Temp:Decomp Text:400F,204C
Vapor Pres:15.00 @68F
Vapor Density:> AIR
Spec Gravity:0.97
Viscosity:20-40"#3 ZAHN
Evaporation Rate & Reference:FASTER THAN BUTYL ACETATE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:66.41
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING. FUMES MAY CONTAIN CARBON
MONOXIDE AND DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
INCINERATE IN AN APPROVED FACILITY. EPA HAZARDOUS WASTE CODE: D001,
IGNITABLE.
======================================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A-1104 PRIMER FOR PLASTISOL COATINGS
Kit Part:Y
Preparer's Name:ROY WHEELDON
CAGE:8L872
CAGE:8L872
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (SARA III) (SEC 304: FINAL RQ 5000 LBS)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 61.8%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL (SEC 304: FINAL RQ 100 LBS)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:VOC PER LITER: 5.78 LBS/GAL (692 GRAMS/LITER); VOC PER
LITER MINUS EXEMPT SOLVENTS & WATER: 5.78 LBS/GAL
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN, EYE, RESPIRATORY AND
GASTROINTESTINAL IRRITATION, POSSIBLY SEVERE. EXCESSIVE INHALATION
MAY PRODUCE CENTRAL NERVOUS SYSTEM DEPRESSION.
Explanation of Carcinogenicity:NONE KNOWN
======================= First Aid Measures =======================
First Aid:EYE CONTACT: IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER
FOR AT LEAST 15 MINUTES. SEEK MEDICAL ATTENTION. SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING. WASH THOROUGHLY WITH SOAP AND WATER.
INHALATION: SEEK IMMEDIATE MEDICAL ATTENTION. DO NOT INDUCE
VOMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:16.0F,-8.9C
Lower Limits:1.8
Upper Limits:19.0
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS WITH
FULL FACEPIECE. COOL CONTAINERS IN VICINITY WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:KEEP ALL IGNITION SOURCES AWAY. GROUND
ALL CONTAINERS. VAPORS MAY TRAVEL TO SOURCE OF IGNITION AND CAUSE
FLASHBACK. FIRE CAUSES ACID SMOKE AND/OR FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. SMALL SPILLS:
TAKE UP WITH ABSORBENT MATERIAL. LARGE SPILLS: DAM AND RECOVER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID HIGH TEMPERATURE AREA AND
IGNITION SOURCES. ALL HANDLING EQUIPMENT SHOULD BE GROUNDED AND
EXPLOSION PROOF. AVOID ALL PERSONAL CONTACT.
Other Precautions:WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROVED SELF-CONTAINED BREATHING APPARATUS
IF NECESSARY.
Ventilation:LOCAL EXHAUST: NECESSARY. MECHANICAL (GENERAL): NECESSARY.
Other Protective Equipment:SAFETY SHOWER. EYE WASH STATION.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:165F,74C
Vapor Pres:85 @ 20C
Vapor Density:2.4
Spec Gravity:0.86 (WATER=1)
Evaporation Rate & Reference:4.6 (BU AC=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:CLEAR TO AMBER LIQUID, KETONE ODOR
Percent Volatiles by Volume:86
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:STRONG ACIDS OR OXIDIZERS, HIGH
TEMPERATURES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
MISCELLANEOUS HYDROCARBON
Conditions to Avoid Polymerization:STRONG OXIDIZERS, ALL IGNITION
SOURCES.
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO STATE, FEDERAL, AND LOCAL
REGULATIONS. HAZARDOUS WASTE CODE: F005, D001, U159, FLAMMABLE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PENNZOIL HD MOTOR OIL SAE 10W-30
CAGE:KO548
CAGE:01326
CAGE:KO548
CAGE:NO728
============= Composition/Information on Ingredients =============
Ingred Name:BASE LUBRICATING OIL MIXTURE
Fraction by Wt: 75-90%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DETERGENT/INHIBITOR SYSTEM, PROPRIETARY
Fraction by Wt: 5-15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:VISCOSITY INDEX IMPROVER, PROPRIETARY
Fraction by Wt: 5-15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POUR POINT DEPRESSANT, PROPRIETARY
Fraction by Wt: <1.00%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:PRACTICALLY NON-IRRIT UPON DIRECT
CONTACT.SKIN:MINIMALLY IRRIT.PROL/REP CONTACT MAY RESULT IN CONTACT
DERM,MORE SUSCEPTABLE TO OTHER IRRIT,SENS,DISEASE.PROL/REP CONTACT
MAY RESULT IN OIL ACNE.PHOT OSENSITIVITY.INHAL:NOT EXPECTED TO
PRESENT HAZ @AMB TEMP.INGEST:RELATIVELY NON-TOXIC.LAXATIVE
PROPERTIES,ADB CRAMPS,DIAR
Explanation of Carcinogenicity:PER MSDS:NOT CARCINOGENIC ACCORDING TO
OSHA HAZ COMM STD.USED GASOLINE-ENGINE MOTOR OILS CARCINOGENIC BY
IARC.
Effects of Overexposure:CONTACT
DERMATITIS:DRYNESS,CHAPPING,REDDENING.OIL ACNE:BLACKHEADS
W/POSSIBLE SECONDARY INFECTION. PULM DISEASE SUCH AS CHRONIC LUNG
INFLAMM:SHORTNESS OF BREATH,COUGH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH W/LG AMTS OF WATER & CONT FLUSHING TIL IRRTI
SUBSIDES.MATL HOT TREAT FOR THERM BURNS.TAKE TO HOSP IMMED.
SKIN:REMOVE CONTAMIN CLOTH.WASH THOROUGHLY W/SOAP/WATER.MATL HOT
SUBMERG INJURE D AREA IN COLD WATER.IF SEVERELY BURNEDREMOVE TO
HOSP IMMED.INHAL:NOT EXPECTED TO PRESENT EXPO @AMB TEMP.INGEST:DO
NOT INDUCE VOMIT.SEEK MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:360F,182C
Autoignition Temp:Autoignition Temp Text:>800F
Lower Limits:NO DATA
Upper Limits:NO DATA
Extinguishing Media:USE DRY CHEMICAL, FOAM, OR CARBON DIOXIDE.
Fire Fighting Procedures:H2O INEFFECTIVE BUT CAN USE TO COOL
HEAT/FLAME-EXPO CNTNR.EXERCISE CAUTION WHEN USING WATER/FOAM AS
FROTHING OCCUR ESPECIALLY SPRAYED INTO CNTNR W/HOT/BURN LIQ.
Unusual Fire/Explosion Hazard:DENSE SMOKE MAY BE GENERATED WHILE
BURNING.CARBON MONOXIDE, CARBON DIOXIDE & OTHER OXIDES MAY BE
GENERATED AS PRODUCTS OF COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:CONSULT HELATH EFFECT/PERS HEALTH PROT/FIRE
PROT/REACTIVITY SECTIONS.NOTIFY APPROP AUTHORITIES OF SPILL.CONTAIN
IMMED.DON'T ALLOW TO ENTER SEWER/WATERCOURSES.REMOVE ALL IGN
SOURCES.ABSORB W/APPROPR IN ERT MATL(SAND,CLAY,ETC)LG SPILL PICK
UPW/(SUPPLE)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T TRANSFER TO UNMARKED CNTNR.STORE
IN CLSD CNTNR AWAY FRM HEAT/SPARK/OPN FLAME/OXIDIZ MATL.FIRE
EXTINGUISHERS SHOULD BE KETP READILY AVAILABLE.
Other Precautions:SEE NFPA 30 & OSHA 1910.106-FLAMM/COMBUST LIQ.AVOID
CONSUMPTION OF FOOD/BEV IN WORKAREAS WHERE HYDROCARBONS
PRESENT.MIXTURE MAY BE FORMULATED IN PART W/COMPONENTS BOUGHT FRM
OTHER CO.MANY INSTANCE(ESP EC WHEN PROPRIETARY/TRADE SECRETS (SUP)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESP PROTECTION NOT REQUIRED UNDER CONDITIONS OF
NORMAL USE.IF VAP/MIST GENERATED WHEN MATL IS HEATED/HNDLD USE
ORGANIC VAPOR RESP W/DUST/MIST FILTER.ALL RESPIRATORS MUST BE NIOSH
CERTIFIED.DON'T USE COMPRESSED OXY IN HYDROCARBON ATMOSPHERS
Ventilation:PROVIDE ADEQUATE VNETI IAW GOOD ENGINEERING PRACT WHEN
VAP/MIST GENERATED WHEN HEATED/HNDL TO MAINTAIN CONCE BEL LIMITS.
Other Protective Equipment:FOR SPLASHING CONDITIONS/PROL/REP EXPO USE
PLAST FCSHIELD/SPLASH-PROOF SAF GOGG,IMPERV
CLOTH(BOOT,APRON,ETC),COVER SKIN.
Work Hygienic Practices:WASH SOIL CLOTH;PROPERLY DISPO CONTAMIN LEATHER
ART WHICH CAN'T BE DECONTAM.WASH HAND/FACE W/SOAP/H2O BEF
EAT/DRINK/SMOK
Supplemental Safety and Health
SPILL:VAC PUMPS/SHOVELS/BUCKETS/OTHER MEANS.PLACE IN DR/OTHER SUITABLE
CNTNR. DISPO:@APPROVED FACILITY.MATL SHOULD BE RECYCLED IF
POSSIBLE.CONTAINS SARA TITLE III SEC 313 CHE:ZN CMPDS:1.5%. OTHER
PREC AUT:USE)PENNZOIL MUST RELY UPON HAZ EVALUATION OF SUCH COMPO
SUBMITTED BY PROD MFG/IMPORTER.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>800F,>427C
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:0.876
pH:NP
Viscosity:NP
Evaporation Rate & Reference:NA
Solubility in Water:NIL
Appearance and Odor:CLEAR, ORANGE LIQUID, LUBE OIL ODOR.
Percent Volatiles by Volume:NA
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL DISPO MUST COMPLY W/FED/STATE/LOC
REGS.SPILL/DISCARDED MATL MAY BE REG WASTE REFER TO SATE/LOC
REGS.REG SOLVENTS USED TO CLEAN UP SPILL MATL RESULTING WASTE
MIXTURE MAY BE REGULATED.DOT REGS MAY A PPLY FOR TRANSPO MATL.MAY
BE LANDFILL/INCINE(SUPP)
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:ELASTOMERIC SEAL KOTE
CAGE:0Z0A9
CAGE:0Z0A9
============= Composition/Information on Ingredients =============
Ingred Name:NATURAL CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
= Wt:42.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:ETHYLENE GLYCOL
CAS:107-21-1
RTECS #:KW2975000
= Wt:1.
ACGIH STEL:C127 MG/M3;C50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
= Wt:2.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:AMORPHOUS SILICA
CAS:112926-00-8
RTECS #:VV7315000
= Wt:.2
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:10 MG/M3
Ingred Name:PROPRIETARY INGREDIENTS
= Wt:55.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:EYES: MAY IRRITATE. SKIN:
IRRITATION/DERMATITIS. INHALATION: IRRITATION TO NOSE & THROAT. CNS
DEPRESSION. INGESTION: MAY CAUSE SOME EFFECTS.
Explanation of Carcinogenicity:AMORPHOUS SILICA.
Effects of Overexposure:IRRITATION, DRYNESS OF SKIN, HEADACHES, CHEST
DISCOMFORT, COUGHING, NARCOSIS, NAUSEA, ABDOMINAL DISCOMFORT,
VOMITING, DIARRHEA
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/RUNNING WATER FOR 15 MINS. SKIN:
WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. GIVE
ARTIFICIAL RESPIRATION IF NOT BREATHING. INGESTION: DON'T INDUCE
VOMITING. IF VOMI TING OCCURS SPONTANEOUSLY, KEEP VICTIM'S HEAD
BELOW HIS HIPS TO PREVENT HIS BREATHING THE VOMITUS INTO HIS LUNGS.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2/DRY CHEMICAL
Fire Fighting Procedures:USE SELF CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE GEAR. USE WATER SPRAY TO COOL NEARBY CONTAINERS &
STRUCTURES EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY RUPTURE DUE TO
BUILDUP OF PRESSURE WHEN EXPOSED TO HEAT/FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. EXTINGUISH ALL
IGNITION SOURCES. ENSURE THAT HANDLING EQUIPMENT IS ELECTRICALLY
GROUNDED. SMALL: MOP/WIPE UP & DISPOSE OF IN DOT APPROVED WASTE
CONTAINERS. LARGE: CONTAIN/DI KE W/SOIL/ABSORBENT MATERIAL & THEN
PUMP INTO DOT APPROVED WASTE CONTAINERS/ABSORB W/SORBENT MATERIAL &
PLACE IN DOT APPROVED WASTE CONTAINERS. KEEP OUT OF SEWERS, STORM
DRAINS, SURFACE WATERS & SOIL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAMES.
STORE IN A COOL, DRY PLACE. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT
IN USE & VENT FREQUENTLY & MORE OFTEN IN WARM WEATHER TO RELIEVE
PRESSURE. DON'T USE PRESSURE T O EMPTY CONTAINER. ALWAYS OBEY
HAZARD WARNINGS & HANDLE EMPTY CONTAINERS AS IF THEY WERE FULL.
Other Precautions:VENT CONTAINERS WHICH ARE ESSENTIALLY EMPTY AS THEY
WILL RETAIN PRODUCT RESIDUE & VAPORS THAT COULD DEVELOP EXCESS
PRESSURE. AVOID CONTACT W/EYES, SKIN & CLOTHING. AVOID BREATHING
VAPORS, SPRAY/MIST. WEAR APPROPRIATE PERSONAL PROTECTIVE
EQUIPMENT. PROVIDE ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED CANISTER RESPIRATOR WHERE
EXPOSURE IN EXCESS OF PERMISSIBLE LIMITS ARE ANTICIPATED/IN THE
ABSENCE OF ADEQUATE ENVIRONMENTAL CONTROLS AT POINT OF USE.
Ventilation:LOCAL MECHANICAL EXHAUST VENTILATION CAPABLE OF MAINTAINING
EMISSIONS AT POINT OF USE BELOW PEL.
Other Protective Equipment:LONG-SLEEVED SHIRT, TROUSERS, RUBBER BOOTS,
RUBBER APRON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:GRAY W/STRONG AMMONIA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, BASES, STRONG OXIDIZING MATERIALS
Stability Condition to Avoid:HEAT, SPARKS, FLAMES & OTHER IGNITION
SOURCES
Hazardous Decomposition Products:CO, CO2, UNIDENTIFIED ORGANIC
COMPOUNDS IN BLACK SMOKE, THERMAL DECOMPOSITION MAY YIELD ACRYLIC
MONOMERS
==================== Disposal Considerations ====================
Waste Disposal Methods:EMPTY CONTAINERS CAN HAVE RESIDUES, GASES &
MISTS & ARE SUBJECT TO PROPER WASTE DISPOSAL. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HEXAMETHYLENE DIISOCYANATE, 118 8200, 906735
CAGE:GO467
CAGE:ACRSR
CAGE:GO467
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE, 1,6-DIISOCYANATO-; (HEXAMETHYLENE DIISOCYANATE)
(CERCLA)
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:HARMFUL IF INHALED. VAPOR
IRRITATING. MAY CAUSE RESPIRATORY SENSITIZATION W/ASTHMA-LIKE
REACTION. SKIN:CAUSES BURNS. MAY CAUSE ALLERGIC REACTION. HARMFUL
IF ABSORBED THROUGH SKIN. EYE:CAUSE S SEVERE BURNS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY. IF SYMPTOMS ARE PRESENT, CALL MD. SKIN:IMMEDIATELY
FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATT
ENTION IF SYMPTOMS ARE PRESENT AFTER WASHING. EYE:IMMEDIATELY FLUSH
W/PLENTY OF WATER FOR AT LEAST 15 MINUTES & CALL MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:284F,140C
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
USE WATER W/CAUT & IN FLOODING AMTS. MATL REACTS W/WATER. WATER MAY
BE INEFT IN FIGHTING FIRE. USE (SUPDAT)
Unusual Fire/Explosion Hazard:FIRE/EXCESSIVE HEAT MAY PRDCE HAZ DECOMP
PRODS. REACTS W/WATER. FIRE/EXCESSIVE HEAT MAY RESULT IN VIOLENT
RUPTURE OF CNTNR DUE TO BULK POLYMERIZATION.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB MATERIAL IN VERMICULITE OR OTHER
SUITABLE ABSORBENT & PLACE INTO IMPERVIOUS CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CONTACT W/OXIDIZING
MATERIALS. KEEP CONTAINER TIGHTLY CLOSED & AWAY FROM ANY CONTACT
W/WATER, ACIDS, STRONG BASES, METALS, AMINES/ALCOHOLS.
Other Precautions:DO NOT ADD WATER TO CLSD CNTNR SINCE RXN MAY RSLT IN
VIOLENT RUPTURE OF CNTNR. STORE IN COOL, DRY PLACE. REFRIGERATION
REQUIRED, BUT KEEP FROM FREEZING. SINCE EMPTY CNTNR RETAINS PROD
RESIDUE, FOLLOW LBL WARNINGS EVEN AFTER CNTNR IS EMPTY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR
SHOULD BE WORN IF NEEDED.
Ventilation:GOOD GENERAL ROOM VENTILATION SHOULD BE USED. LOCAL EXHAUST
MAY BE NEEDED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . PROTECTIVE CLOTHING SHOULD BE WORN.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT:NEGLIGIBLE (WT). FIRE FIGHT PROC:WATER SPRAY TO KEEP
FIRE-EXPOSED CNTNRS COOL. FIGHT FIRE FROM PROTECTED LOCATION. HAZ
DECOMP PROD:DECOMP MAY PRODUCE CYANIDE FUMES. EYE PROT:& FULL
LENGTH FACE SHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:415F,213C
Vapor Pres:0.03 @ 20C
Spec Gravity:1.05 (H*2O=1)
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:DECOMPOSES
Appearance and Odor:COLORLESS LIQUID.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, WATER, ACIDS, STRONG BASES, METALS, AMINES, ALCOHOLS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:COMBUST WILL PRDCE CARBON DIOXIDE &
PROBABLY CARBON MONOXIDE. OXIDES OF NITROGEN MAY ALSO BE PRESENT.
HEATING TO(SUPDAT)
Conditions to Avoid Polymerization:MAY OCCUR UPON HEATING.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE BY INCINERATION OR CONTRACT W/LICENSED
CHEMICAL WASTE DISPOSAL AGENCY. DISCHARGE, TREATMENT OR DISPOSAL
MAY BE SUBJECT TO FEDERAL, STATE OR LOCAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CHLORODIMETHYLSILANE 14420-7
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:CHLORODIMETHYLSILANE, 98%
CAS:1066-35-9
Fraction by Wt: 98%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, INHALED, OR
ABSORBED THROUGH SKIN. MATERIAL IS EXTREMELY DESTRUCTIVE TO TISSUE
OF THE MUCOUS MEMBRANES AND UPPER RESPIRATORY TRACT, EYES AND SKIN.
INHALATION MAY BE FATAL AS A RE SULT OF SPASM, INFLAMMATION AND
EDEMA OF THE LARYNX AND BRONCHI, CHEMICAL PNEUMONITIS AND PULMONARY
EDEMA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:MAY INCLUDE BURNING SENSATION, COUGHING,
WHEEZING, LARYNGITIS, SHORTNESS OF BREATH, HEADACHE, NAUSEA AND
VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER
FOR AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING AND
SHOES. INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRA TION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
CALL MD. WASH CONTAMINATED CLOTHING BEFORE REUSE. INGEST: CALL MD
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:-20F,-29C
Lower Limits:3%
Upper Limits:20%
Extinguishing Media:CO2, DRY CHEMICAL POWDER
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT TO PREVENT CONTACT WITH SKIN AND
EYES. EXTREMELY FLAMMABLE.
Unusual Fire/Explosion Hazard:VAPOR MAY TRAVEL CONSIDERABLE DISTANCE TO
SOURCE OF IGNITION & FLASH BACK. WATER HYDROLYZES MATERIAL
LIBERATING ACIDIC GAS WHICH IN CONTACT WITH (SEE SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. SHUT OFF ALL SOURCES OF
IGNITION. WEAR NIOSH/MSHA APPROVED SCBA, RUBBER BOOTS & HEAVY
COVERED CONTAINERS USING NON-SPARKI NG TOOLS AND TRANSPORT
OUTDOORS.
Neutralizing Agent:DRY LIME, SODA ASH OR SAND
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE HARMFUL VAPOR. KEEP
TIGHTLY CLOSED. KEEP AWAY FROM HEAT, SPARKS, AND OPEN FLAME. HANDLE
AND STORE UNDER NITROGEN. REFRIGERATE.
Other Precautions:CORROSIVE. MOISTURE SENSITIVE. DO NOT GET IN EYES, ON
SKIN OR CLOTHING. AVOID PROLONGED OR REPEATED EXPOSURE. NO SMOKING
IN AREA OF USE. DO NOT USE IN THE GENERAL VICINITY OF ARC WELDING,
OPEN FLAMES OR HOT SURFACES. HEAT (SEE SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:RUBBER BOOTS AND OTHER PROTECTIVE CLOTHING,
SAFETY SHOWER AND EYE BATH
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE AND BEFORE
EATING, DRINKING, SMOKING OR USING SANITARY FACILITIES .
Supplemental Safety and Health
EXPLO HAZ: METAL SURFACES CAN GENERATE FLAMMABLE AND/OR EXPLOSIVE
HYDROGEN GAS. EMITS TOXIC FUMES UNDER FIRE CONDITIONS. CONTAINER
EXPLOSION MAY OCCUR UNDER FIRE CONDITIONS. THERMAL DECOMP PRODS MAY
I NCLUDE HCL AND PHOSGENE . OTHER PREC: AND/OR UV RADIATION MAY
CAUSE THE FORMATION OF HCL AND/OR PHOSGENE .
================== Physical/Chemical Properties ==================
HCC:F6
Boiling Pt:B.P. Text:94.5F,34.7C
Melt/Freeze Pt:M.P/F.P Text:-168F,-111C
Vapor Pres:143 @ 20C
Vapor Density:4
Spec Gravity:0.852
Appearance and Odor:COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG BASES, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:MAY DECOMPOSE ON EXPOSURE TO MOIST AIR OR
WATER.
Hazardous Decomposition Products:TOXIC FUMES OF: CO, CO2, SILICON
OXIDE, HCL GAS. PHOSGENE .
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER BUT EXERT EXTRA CARE IN IGNITING AS THIS
MATERIAL IS HIGHLY FLAMMABLE. OBSERVE ALL FEDERAL, STATE AND LOCAL
LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:75685-00245,ALMOND,RED DEVIL GLOSS POLYURETHANE (SUP DAT)
CAGE:THOMP
CAGE:63272
CAGE:THOMP
============= Composition/Information on Ingredients =============
Ingred Name:C.I. PIGMENT RED 49; (BARIUM LITHOL RED) %: 0.01-6.78
CAS:1103-38-4
Fraction by Wt: <6.78%
OSHA PEL:0.5 MG/M3 (MFR)
ACGIH TLV:0.5 MG/M3 (MFR)
Ingred Name:NAPHTHA, HEAVY STRAIGHT RUN; (NAPHTHA (PETROLEUM), HEAVY
STRAIGHT-RUN)
CAS:64741-41-9
Fraction by Wt: 1-2%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC
CAS:64742-88-7
Fraction by Wt: 12-35%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 5-15%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE) %: 0.0001-25.0
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <25%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:VOLATILE ORGANIC COMPOUND: 450 G/L MAXIMUM
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: AVOID PROLONGED
BREATHING OF VAPOR OR SPRAY MIST. SKIN/EYES/INGESTION: NONE
EXPECTED. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PREEXISTING LUNG DISORDERS MAY BE
AGGRAVATED BY INHALATION DURING USE.
======================= First Aid Measures =======================
First Aid:INHALATION: IF BREATHING IS AFFECTED, IMMEDIATELY MOVE TO
FRESH AIR. SKIN: IN KEEPING WITH GOOD HYGIENIC PRACTICES, WASH
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, CONTACT MD.
EYES: AS IN THE CASE WHEN ANY FOREIGN MATTER CONTACT THE EYE,
RINSE THOROUGHLY WITH WATER. INGESTION: CONTACT MD OR A POISON
CONTROL CENTER.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:104F,40C
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEM/CARBON DIOXIDE. DO NOT
USE DIRECT STREAM OF WATER. PROD WILL FLOAT & CAN BE (SUP DAT)
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COMBUSTIBLE. USE WATER SPRAY TO COOL FIRE-EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:COMBUST. CONTAINS PETRO DISTILS. KEEP
AWAY FROM HEAT & FLAME. CONTRS EXPOSED TO INTENSE HEAT FROM FIRES
SHOULD BE COOLED W/WATER TO PVNT VAP PRESS (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SMALL SPILLS W/SAND/OTHER SUITABLE
ABSORB MATL & PLACE IN CONTR FOR DISP. FOR LARGE SPILLS, AREA MAY
BE SLIPPERY, DIKE AROUND SPILL W/ABSORB MATL. TRANSFER LIQS &
CONTAM DIKING MATL TO SEPARATE , SUITABLE CONTRS FOR
RECOVERY/DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:COMBUSTIBLE. CONTAINS PETROLEUM
DISTILLATES. AVOID PROLONGED BREATHING OF VAPOR. KEEP OUT OF REACH
OF CHILDREN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID PROLONGED BREATHING OF VAPOR. USE NIOSH
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
TRADE NAME/PART #: OIL ENAMEL-NAT VOC-ALL SHADES. % VOLAT: 53.3-70.1.
EXTING MEDIA: REIGNITED ON SURF OF WATER. EXPLO HAZ: BUILD-UP WHICH
COULD RSLT IN CONTR RUPTURE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:220F,104C
Vapor Pres:<55 @ 20C
Vapor Density:4.8
Spec Gravity:0.94-1.32
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORED, VISCOUS LIQUID WITH PETROLEUM SOLVENT ODOR
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, ALL SOURCES OF
HEAT OR IGNITION.
Hazardous Decomposition Products:HYDROCARBON FUMES, SMOKE, CARBON
MONOXIDE (WHERE COMBUSTION IS INCOMPLETE) MAY BE FORMED DURING
THERMAL DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: M-20-600, MAGIC LENS CLEANING ANTI-FOGGING (SUPP DATA)
Cage: IO045
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 05732
Box: 29
Cage: IO045
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: SLIGHT IRRITATION OF EYES OR SKIN.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
First Aid: INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTR
RESP)(FP N). EYE: FLUSH LIBERALLY W/WATER FOR AT LEAST 15 MINUTES. PRODUCT
WILL NOT CAUSE DAMAGE TO EYE. SKIN: WASH OFF W/WATER. INGEST: TR EAT AS
ALCOHOL IF INGESTED. CONSULT MD.
=======================================================
Handling and Disposal
=======================================================
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE &
FEDERAL REGULATIONS (FP N).
Handling And Storage Precautions: NORMAL PRECAUTION FOR WATER ALCOHOL PRODUCTS.
NOT HAZARDOUS OR FLAMMABLE.
Other Precautions: NONE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: CC
Flash Point Text: >100F,>38C
Extinguishing Media: CARBON DIOXIDE.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT(FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN (FP N). AVOID CONCENTRATED VAPORS.
Other Protective Equipment: NONE.
Work Hygienic Practices: NONE.
Supplemental Safety and Health: MFR'S TRADE NAME/PART NO: ANTI-STAT FLUID.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
B.P. Text: 183F,84C
Vapor Pres: 38
Vapor Density: HVR/AIR
Spec Gravity: 0.96 (H*2O=1)
Evaporation Rate & Reference: 1.7 (BUTYL ACETATE=1)
Solubility in Water: COMPLETE
Appearance and Odor: CLEAR; PUNGENT ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE.
Materials To Avoid: NONE.
Hazardous Decomposition Products: NONE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: M-20-600, MAGIC LENS CLEANING ANTI-FOGGING (SUPP DATA)
Cage: IO045
Assigned IND: Y
Company Name: SILICONE/STIRLING
Street: 3401B NEW BRUNSWICK AVE
Zipcode: 07080
Label Required IND: Y
Date Of Label Review: 10/13/1994
Status Code: C
Label Date: 10/13/1994
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: SLIGHT IRRITATION OF EYES OR SKIN.
CHRONIC: NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GRAY PRIMER
CAGE:60020
CAGE:60020
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENTS
Fraction by Wt: 39.8%
Ingred Name:VEHICLE
Fraction by Wt: 42.7%
Ingred Name:SOLVENTS
Fraction by Wt: 13.1%
ACGIH TLV:200PPM
Ingred Name:ADDITIVES
Fraction by Wt: 4.4%
===================== Hazards Identification =====================
Effects of Overexposure:SEVERE EYE IRRIT, DRYING OF SKIN. EXCESS INHALE
CAUSES HEADACHE, DIZZINESS & NAUSEA.
======================= First Aid Measures =======================
First Aid:EYE CONTACT-FLUSH W/WATER. SKIN CONTACT-WASH W/MILD SOAP &
WATER & APPLY SKIN CREAM. INHALTION-REMOVE TO FRESH AIR & CALL A
DR;APPLY ARTIFICIAL RESPIRATION IF NECESSARY.
===================== Fire Fighting Measures =====================
Flash Point:45F TCC 7 C
Lower Limits:1.2
Upper Limits:7.0
Extinguishing Media:WATER SPRAY-CO*2 FOAM CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER INTO RETAINING AREA OR
CONTAINER.AVOID EXPOSURE TO SPARKS, FIRE OR HOT METAL SURFACES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND OPEN
FLAME.USE W/ADEQUATE VENTILATION.AVOID PROLONGED OR REPEATED
CONTACT W/SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF-CNTND BRTHG APPARATUS FOR CONC. ABOVE TLV
Ventilation:LOC EXHAUST-YES
Other Protective Equipment:EYE BATH & SAFETY SHOWER
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:230-232
Vapor Pres:38
Vapor Density:4.1
Spec Gravity:1.26
Evaporation Rate & Reference:N-BUT AC 1.5
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT,SPARKS, OPEN FLAME & FIRES
Hazardous Decomposition Products:THERM DECOMP MAY YIELD
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS OR DISPOSA OF
IAW LOCAL,STATE & FEDERAL REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LITHIUM, SULFUR DIOXIDE BATTERY
CAGE:7X634
CAGE:21938
CAGE:7X634
============= Composition/Information on Ingredients =============
Ingred Name:LITHIUM METAL
CAS:7439-93-2
RTECS #:OJ5540000
Fraction by Wt: 4%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SULFUR DIOXIDE (SARA III)
CAS:7446-09-5
RTECS #:WS4550000
Fraction by Wt: 30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 PPM
ACGIH TLV:2 PPM/5 STEL; 9394
Ingred Name:ACETONITRILE (SARA III)
CAS:75-05-8
RTECS #:AL7700000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:40PPM
ACGIH TLV:40PPM/60STEL; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE EXPOSURE TO SULFUR DIOXDE IS
DANGEROUS TO EYES, NOSE, THROAT, SKIN, UPPER RESPIRATORY TRACT AND
BRONCHI CAN PRODUCE EDEMA OF LUNGS AND GLOTTIS. RESPIRATORY
PARALYSIS MAY BE FATAL. LITHIUM MAY DA MAGE SKIN.
Explanation of Carcinogenicity:NONE.
Effects of Overexposure:IRRITATION OF NOSE, THROAT, EYES AND SKIN,
SUFFOCATING ODOR.
Medical Cond Aggravated by Exposure:EXPOSURE TO SULFUR DIOXIDE IS
PRACTICALLY DANGEROUS TO PERSONS SUFFERING FROM ASTHMA AND OTHER
RESPIRATORY DISEASES.
======================= First Aid Measures =======================
First Aid:IF CELL VENTS, PERSONNEL SHOULD BE EVACUATED FROM
CONTAMINATED AREAS. ARTIFICIAL RESPIRATION SHOULD BE GIVEN IF
BREATHING STOPS. SUMMON MEDICAL HELP.
===================== Fire Fighting Measures =====================
Flash Point:42.0F,5.6C CH3CN
Lower Limits:4.4
Upper Limits:16
Extinguishing Media:LITH-X FOR LITHIUM FIRE, USE WATER TO KEEP CELLS
COOL.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:BATTERIES CAN VENT WHEN SUBJECT TO
EXCESSIVE HEAT, EXPOSING CELL CONTENTS.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP OUT OF AREA UNLESS A SELF-CONTAINED
PROVIDE MAXIUM VENTILATION TO CLEAR OUT TOXIC GASES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:LI/SO2 CELLS AND BATTERIES SHOULD BE
STORED IN A WELL-VENTILATED, SPRINKLER PROTECTED, NONCOMBUSTIBLE
STRUCTURE WITH ADEQUATE CLERANCE BETWEEN WALLS.
Other Precautions:DO NOT REMOVE OR BYPASS PROTECTIVE ELECTRICAL OR
THERMAL FUSES. DO NOT HEAT ABOVE 200F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF-CONTAINED BREATHING APPARATUS.
Ventilation:IN THE EVENT OF VENTS, PROVIDE MAXIMUM POSSIBLE AMOUNTS OF
VENTILATION.
Other Protective Equipment:SEE STEPS TO BE TAKEN IN CASE MATERIAL IS
RELEASED OR SPILLED.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:Z6
Boiling Pt:B.P. Text:14F,-10C
Melt/Freeze Pt:M.P/F.P Text:104F,40C
Vapor Pres:760 MMHG
Vapor Density:2.25
Spec Gravity:1.42
Appearance and Odor:LI-SOFT, SILVERY META. CH3CN-COLORLESS LIQUID,
ACRID ODOR. SO2-COLORLESS GAS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:BATTERY CONTAINS HERMATICALLY SEALED CELLS
& IS NONREACTIVE PROVIDED BATTERY INTEGRITY IS MAINTAINED & CELL
REMAINS ASIS
Conditions to Avoid Polymerization:HEATING, MECHANICAL ABUSE THAT MAY
PRODUCE VENTING, ELECTRICAL ABUSE SUCH AS RECHARGING, VOLTAGE
REVERSAL, SHORT CIRCUIT
==================== Disposal Considerations ====================
Waste Disposal Methods:CELLS ARE CONSIDERED TO BE A HAZARDOUS WASTE
BECAUSE OF ACTIVITY. LAND DISPOSAL IS PROHOBITED UNLESS CELLS ARE
TREATED SO AS TO RENDER THEM NON-TOXIC.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METCOLOY #2 WIRE
CAGE:FO880
CAGE:FO880
CAGE:39918
============= Composition/Information on Ingredients =============
Ingred Name:CARBON
CAS:7440-44-0
RTECS #:FF5250100
Other REC Limits:7MG/M3 STEL
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:MANGANESE
CAS:7439-96-5
RTECS #:OO9275000
Other REC Limits:1 MG/M3 FUMES
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
Other REC Limits:0.1 MG/M3 AS SOL NI
OSHA PEL:1 MG(NI)/M3
ACGIH TLV:1 MG(NI)/M3
Ingred Name:SILICON.
CAS:7440-21-3
RTECS #:VW0400000
Other REC Limits:5 MG/M3 RDUST
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CHROMIUM
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON(III) OXIDE; (IRON (FE2O3))
CAS:1309-37-1
RTECS #:NO7400000
Other REC Limits:NONE SPECIFIED BY M.
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SHORT TERM EXPOSURE TO WELDING FUMES,
GASES OR DUST MAY RESULT IN DISCOMFORT SUCH AS DIZZINESS, NAUSEA,
FEVER, DRYNESS AND/OR IRRITATION OF NOSE, THROAT AND EYES. SKIN
SENSITIVITY MAY ALSO BE NOTED. A CUTE EXPOSURE FROM SOME TOXIC
GASES MAYCAUSE PULMONARY EDEMA, ASPHYXIATION AND EXCESSIVE EXPOSURE
CAN BE FATAL.
Explanation of Carcinogenicity:NICKEL AND CHROMIUM LISTED BY NTP AND
IARC AND POSSIBLE CARCINOGENS.
Effects of Overexposure:PARKINSON'S; ASTHENIA, INSOMNIA, METAL FUME
FEVER; DRY THROAT, COUGH, TIGHT CHEST, DYSPENEA, LOW BACK PAIN;
VOMIT, MALAISE; FATG., SENSITIVE DERMATITIS; ALLERGIC NASAL
CAVITIES ASTHMA., HISTOLOGIC FIB ROSIS, PNEUMOCONIOSIS, SKIN AND
EYE IRRITATION.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH SUFFICIENT AMOUNTS OF WATER FOR AT LEAST 15
MIN. IF IRRITATION PERSISTS, CONSULT PHYSICIAN. SKIN:WASH WITH SOAP
AND WATER TO REMOVE MATERIAL. INHAL:REMOVE TO FRESH AIR. INGESTION:
GET M EDICAL HELP IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE CLASS D FIRE EXTINGUISHER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . TREAT AS A METALLIC FIRE.
Unusual Fire/Explosion Hazard:MODERATE FIRE HAZARD IN FORM OF DUST WHEN
EXPOSED TO FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
HANDLING WIRE.
INDICATED: FOR COMBUSTION SPRAYING USE SHADE #5, FOR ARC SPRAYING
USE #9.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR FOR DUST/FUMES/ MISTS
SHOULD BE WORN AT ALL TIMES DURING THERMAL SPRAY PROCESS TO PROTECT
OPERATOR FROM DUST AND FUMES.
Ventilation:VENTILATION EQUIPMENT DESIGNED TO CREATE AN AIR VELOCITY OF
200 FPM.
Other Protective Equipment:EAR PROT MUST BE WORN WHEN OPERATOR IS
SUBJECTED TO EXCESS NOISE LEVELS. (SEE OSHA REQUIREMENTS).
ALUMINIZED (SUPP DATA)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PROT EQUIP:APRON IS TO BE WORN DURING ARC SPRAYING.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:266F,130C
Spec Gravity:7.8
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WIRE; NO ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:THINNER, AIR CRAFT COATING
Preparer's Name:DAVID SHIPP
CAGE:0LWP6
CAGE:4N760
CAGE:0LWP6
============= Composition/Information on Ingredients =============
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 31%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9596
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 52%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300STEL;9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ISOBUTYL KETONE (HEXONE) (SARA 313) (CERCLA)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 17%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM/75 STEL; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MODERATE IRRITATION, REDNESS,
TEARING. SKIN:SLIGHT IRRIT. EXCESSIVE INHALE:CAN CAUSE NASAL &
RESPIRATORY IRRITATION & CENTRAL NERVOUS SYSTEM EFFECTS, DIZZINESS,
WEAKNESS, FATIGUE, NAUSEA, HEADACH ES & POSSIBLE UNCONSCIOUSNESS.
SWALLOWED:GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING & DIARRHEA.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYES:MODERATE IRRITATION, REDNESS, TEARING.
SKIN:SLIGHT IRRITATION. EXCESSIVE INHALE:CAN CAUSE NASAL &
RESPIRATORY IRRITATION & CENTRAL NERVOUS SYSTEM EFFECTS, DIZZINESS,
WEAKNESS, FATIGUE, NAUSEA, HE ADACHES & POSSIBLE UNCONSCIOUSNESS.
SWALLOWED:GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING & DIARRHEA.
Medical Cond Aggravated by Exposure:METHYL ETHYL KETONE MAY ACCELERATE
ONSET OF PERIPHERAL NEUROPATHY CAUSED BY METHYL N-BUTYL KETONE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INH ALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. GIVE 1-2
GLASSES OF WA TER IF CONSCIOUS. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:32.0F,0.0C
Lower Limits:1.7
Upper Limits:NOT GIVEN
Extinguishing Media:REGULAR FOAM OR WATER FOG OR CARBON DIOXIDE OR DRY
CHEMICAL
Fire Fighting Procedures:DO NOT USE TORCHES ON/NEAR DRUM(EVEN EMPTY)
RESIDUE CAN IGNITE. GROUND/BOND WHEN TRANSFERING MATERIAL. VAPOR
>THAN AIR, MAY TRAVEL/IGNITE AT DISTANT LOCATION
Unusual Fire/Explosion Hazard:WEAR SELF-CONTAINED BREATHING APPARATUS
WITH A FULL FACEPIECE OPERATED IN POSITIVE PRESSURE DEMAND MODE
WHEN FIGHTING FIRES.
================== Accidental Release Measures ==================
Spill Release Procedures:SM:ABSORB LIQ ON PAPER,VERMICULITE,FLOOR
ABSORB. LG:ELIM ALL IGNITE SOURCES. REMOVE PERSONS NOT WEARING
PROTECTIVE EQUIP. STOP SPILL AT SOURCE. DIKE AREA, PREVENT SPREAD,
PUMP LIQ TO SALVAGE TANK, TAK E UP REMAINING W/SAND, ETC. SHOVEL
INTOCONTAINER
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINERS OF MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED SINCE EMPTY RETAINS RESIDUES(VAPOR, LIQ,
SOLID)ALL HAZARD PRECAUTIONS GIVEN MUST BE OBSERVED.
Other Precautions:WASH CONTAMINATED CLOTHING BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE LIMIT/COMPONENT IS
EXCEEDED:NIOSH/MSHA APPROVED AIR SUPPLIED RSPRTR IF NO
ENVIRONMENTAL CONTROL. OSHA REGS PERMIT OTHER NIOSH/MSHA
RSPRTR(NEGATIVE PRESSURE TYPE)(SEE SAFETY EQUIPMENT SUPPL IER &
ENGINEER/ADMINISTRATIVE CONTROLS)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENT TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:175F/79.4C
Melt/Freeze Pt:M.P/F.P Text:-20F,-29C
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:49.1 MMHG
Vapor Density:3.4(AIR=1)
Spec Gravity:0.839
Evaporation Rate & Reference:16.8 (ETHYL ETHER=1)
Solubility in Water:MODERATE
Appearance and Odor:CLEAR, LITTLE IF ANY COLOR; CHARACTERISTIC ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS, CARBON
DIOXIDE AND CARBON MONOXIDE, VARIOUS HYDROCARBONS, ETC.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL SPILL: DISPOSE OF IN ACCORDANCE WITH ALL
LOCAL, STATE & FEDERAL REGULATIONS. LARGE SPILL: DISPOSE OF IN
ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MAS ALCOHOL/AMMONIA CONTROL LEVEL 1
CAGE:0GZ15
CAGE:0GZ15
============= Composition/Information on Ingredients =============
Ingred Name:HUMAN SERUM
CAS:9048-46-8
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:AVOID CONTACT W/EYES, SKIN & MUCOUS
MEMBRANES.
Effects of Overexposure:HANDLE AS IF CAPABLE OF TRANSMITTING DISEASE
(HIV, HEPATITIS, ETC.)
======================= First Aid Measures =======================
First Aid:IMMEDIATELY FLUSH AFFECTED AREA W/LARGE AMOUNTS OF WATER. DO
NOT INGEST. OBTAIN MEDICAL ATTENTION IN ALL CASES.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT & HANDLE AS IS CAPABLE OF TRANSMITTING
DISEASE (HIV, HEPATITIS, ETC.) DECONTAMINATE ALL SURFACES COMING
IN CONTACT W/BIOHAZARDOUS MATERIAL USING BLEACH/APPROPRIATE
DISINFECTANT.
======================Handling and Storage ======================
Handling and Storage Precautions:THIS MATERIAL IS PREPARED FROM A HUMAN
SERUM BASE. DONORS HAVE BEEN TESTED BY FDA APPROVED METHODS &
FOUND NEGATIVE FOR ANTIBODIES TO HIV-1 & HIV-2, NON-REACTIVE FOR
HBSAG, & NON-REACTIVE FOR HC. NOR MAL LABORATORY PRECAUTIONS FOR
HANDLING HUMAN SERUM SHOULD BE EXERCISED WHEN USING CONTROL
PRODUCT.
Other Precautions:FOLLOW GOOD LABORATORY PRACTICES WHEN HANDLING THIS
CONTROL MIXTURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:REQUIRED
Ventilation:REQUIRED
Other Protective Equipment:PROTECTIVE CLOTHING
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:AMBER COLORED CLEAR LIQUID W/TYPICAL PROTEIN ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:AUTOCLAVE & DISPOSE AS NON-HAZARDOUS MATERIAL.
DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:PROPER SHIPPING NAME: MARVEL MYSTERY OIL. NOT DOT
REGULATED. UN 1270, UN 1271. REPORTABLE QUANTITY FOR PRODUCT OR ANY
CONSTITUENT GREATER THAN 1% OR 0.1% OF CARCINOGEN. ADDITONAL
LABELING: COMBUSTIBLE LIQUID.
===================== Regulatory Information =====================
SARA Title III Information:SARA REQUIRES EMERGENCY PLANNING BASED ON
THRESHOLD PLANNING QUANTITIES (TPQS) AND RELEASE REPORTING BASED ON
REPORTABLE QUANTITIES (RQ) IN 40 CFR 355 ( USED FOR SARA
302,304,311, AND312). COMPONENTS PRESENT IN THIS PRODUCT AT A
LEVEL WHICH COULD REQUIRE REPORTING UNDER THE STATUE ARE: NONE.
REQUIRES SUBMISSION OF ANNUAL REPORTS OF RELEASE OF TOXIC CHEMICALS
THAT APPEAR IN 4O CFR 372 (FOR SARA 313 ). THIS INFORMATION MUST BE
INCLUDED IN ALL MSDS THAT ARE COPIED AND DISTRIBUTED FOR THIS
MATERIAL. COMPONENTS PRESENT IN THIS PRODUCT AT A LEVEL WHICH COULD
REQUIRE REPORTING UNDER THE STATUTE ARE: N ONE.
Federal Regulatory Information:COMPREHENSIVE ENVIRONMENTAL RESPONSE,
COMPENSATION, AND LIABILITY ACT OF 1980 CERCLA) REQUIRES
NOTIFICATION OF THE NATIONAL RESPONSE CENTER OF RELEASE OF
QUANTITIES OF HAZARDOUS SUBSTANCES EQUAL TO A GREATER THAN THE
REPORTABLE QUANTITIES (RQ) IN 40 CFR 302.4. COMPONENTS PRESENT IN
THIS PRODUCT AT A LEVEL WHICH COULD REQUIRE REPORTING UNDER THE
STATUTE ARE: NONE.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INCO-WELD A WELDING ELECTRODES
CAGE:9Z762
CAGE:9Z762
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL. LD50:(ORAL,RAT) >9,000 MG/KG
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 30-60%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:NIOBIUM
CAS:7440-03-1
Fraction by Wt: 1-5%
Ingred Name:SILICA, CRYSTALLINE - FUSED; (SILICON DIOXIDE).
LD50:(ORAL,RAT) 3,160 MG/KG
CAS:60676-86-0
RTECS #:VV7328000
Fraction by Wt: 1-2%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 3-7%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:VENT: OF ADEQUATE VENTILATION AND/OR NIOSH/MSHA APPROVED
AIR-SUPPLIED RESPIRATORS.
RTECS #:9999999ZZ
Ingred Name:SUPP DATA:CAUSE "METAL FUME FEVER" W/FLU-LIKE SYMPTOMS. ING
5:GI DISTRESS W/SALIVATION, NAUS, VOMIT, DIARRHEA (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:& PAIN, MUSCULAR WEAKNESS, TREMORS, CONVULSIONS,
UNCONSCIOUSNESS, DEATH, SKELETAL ABNORMALITIES & DERMAT.(ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: ING 6:MAY CAUSE CORROSIVE EFFECTS ON MUCOUS
MEMBRANES. INGEST MAY CAUSE ABNORMAL KIDNEY FUNCTION. (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: ING 7:SENSIT, MAY PRODUCE ALLERGIC RXNS. ING
9:CHRONIC INHAL MAY PRODUCE SILICOSIS, IMPAIRMENT OF LUNG FUNCTION.
RTECS #:9999999ZZ
Ingred Name:MP: >1832F,>1000C.
RTECS #:9999999ZZ
Ingred Name:APPEAR & ODOR: CORE; ODORLESS.
RTECS #:9999999ZZ
Ingred Name:CALCIUM CARBONATE. LD50:(ORAL,RAT) 6,450 MG/KG
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 5-10%
OSHA PEL:15MG/M3 TDUST;5RDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CHROMIUM
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 10-30%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 3-7%
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:MANGANESE. LD50:(ORAL,RAT) 9,000 MG/KG
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1-5%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:SODIUM FLUOALUMINATE (SYN: SODIUM ALUMINUM FLUORIDE).
LD50:(ORAL,RAT) 200 MG/KG
CAS:15096-52-3
RTECS #:WA9625000
Fraction by Wt: 5-10%
OSHA PEL:2.5 MG/M3 AS F
ACGIH TLV:2.5 MG/M3 AS F
Ingred Name:SODIUM SILICATE. LD50:(ORAL,RAT) 1133 MG/KG
CAS:1344-09-8
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ELECTRODES MAY CAUSE ALLERGIC RXN IN
INDIV SENSIT TO METAL(S).DUSTS/FUMES MAY ON CONT W/SKIN/EYES
PRODUCE MECH IRRIT.CHRONIC EXPOS MAY CAUSE DERM (SKIN)/CONJ
(EYES).FUMES FROM WELDING MAY POSE LONG TE RM HLTH HAZ.INGS
1,3,5,6,8,9,10: IRRIT OF RESP TRACT.INGS 6,8,10: IRRIT OF EYES &
SKIN.INGS 5,6: IRRIT(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE: GRP 2 (NTP), GRP 2A
(IARC). CHROMIUM: GRP 1 (NTP), GRP 1 (IARC). NICKEL: GRP 2 (NTP),
GRP 1 (IARC).
Effects of Overexposure:HLTH HAZ:OF GI TRACT.INGS 2,10: FIBROSIS OF
LUNGS.ING 1: LRG AMTS INGESTED MAY CAUSE INTESTINAL BLOCKAGE.ING
2:MAY CAUSE ECZEMATOUS ERUPTIONS ON PALMS OF SENSIT INDIV.ING
3:INHAL FOR 6-10 YRS MAY CAUS E SIDEROSIS.PRLNGD EYE CONT MAY CAUSE
RUST BROWN COLORED SPOTS FORMING AROUND PARTICLES & PERM DMG. (SUPP
DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH PARTICLES FROM EYEBALLS W/CLEAN WATER FOR AT LEAST
15 MIN. IF IRRIT PERSISTS, CALL MD. SKIN:WASH W/SOAP & WATER TO
REMOVE ANY METALLIC PARTICLES. IF RASH DEVELOPS, CALL MD.
INHAL:REMOVE FROM EXPOS. IF SEVERE RESP IRRIT PERSISTS, CALL MD.
SOME METAL FUMES CAN PRODUCE ACUTE RXN KNOWN AS "METAL FUME FEVER"
W/SYMP OF CHILLS & FEVER SIMILAR TO FLU. INGEST:CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . SPARKS FROM WELDING IN USER OPER COULD
IGNITE FLAM OR COMBUST LIQUIDS, VAPORS & SOLIDS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM OR SHOVEL ANY SPILLED MATERIAL INTO A
SUITABLE CONTAINER. ALLOY WASTES ARE NORMALLY COLLECTED TO RECOVER
METAL VALUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:MAINTAIN EXPOS<ACCEP EXPOS LIMS.USE INDUSTRIAL
HYGIENE AIR MONITORING TO ENSURE THAT USE OF MATL DOES NOT CREATE
EXPOS WHICH EXCEED REC EXPOS LIMS.ALWAYS USE EXHST VENT IN USER
WELDING OPER.REFER TO A NSI Z49.1 & 29CFR1910 FOR ADDTNL INFO.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION IS NEC WHEN EXPOSURE
LIMITS FOR AIRBORNE CONTAMINANTS ARE EXCEEDED DURING WELDING WITH
THESE ELECTRODES. USE AIR-SUPPLIED RESP IN CONFINED SPACES. USE
ONLY NIOSH/MSHA APPRVD RES P I/A/W 29 CFR 1910.134 RESP PROT.
Ventilation:USE LOCAL EXHST WHEN WELDING. MAINTAIN EXPOS <ACCEP EXPOS
LIMITS. CONFINED SPACES REQ SPECIAL ATTN TO PROVISION (ING 11)
Other Protective Equipment:PROT CLTHG IS REQ WHEN WELDING.WEAR FLAME
RETARDANT CLTHG.SELECT WELDING LENS SHADE FROM AMERICAN WELD
SOCIETY PUB F2.2.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PRODS:OXIDES OF NITROGEN. PHOSGENE CAN BE PRODUCED IF
CHLORINATED SOLV VAPS ARE PRESENT IN USER OPER. EFTS OF OVEREXP:ING
4:INHAL/INGEST CAN PRODUCE POISONING.CHRONIC EXPOS CAN LEAD TO APAT
HY, DROWS, WEAKNESS, SPASTIC GAIT, PARALYSIS & OTHER NEUROLOGICAL
PROBLEMS RESEMBLING PARKINSONISM.FUMES MAY (ING 12)
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:INGRED 16
Spec Gravity:4-6
Appearance and Odor:WELDING ELECTRODES ARE METALLIC SILVER COLORED WIRE
W/FLUX COATING/FLUX (ING 17
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:INGREDS OF FUMES & GASES GEN IN
WELDING MAY INCL METALS, METAL OXIDES, CHROMATES, FLUORIDES, CO,
OZONE, & (SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE OR
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ALCO STA-GON
CAGE:92516
CAGE:92516
============= Composition/Information on Ingredients =============
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: 95%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: NAUSEA, VOMITING, ABDOMINAL
CRAMPS, CYANOSIS, COMA, SKIN AND MUCOUS MEMBRANE LESIONS. CHRONIC:
BORISM (DRY SKIN, SKIN ERUPTIONS, GASTRIC DISTURBANCES).
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN AND
GASTROINTESTINAL PROBLEMS.
======================= First Aid Measures =======================
First Aid:IN CASE OF OVEREXP A PHYS SHOULD BE CONTACTED IMMED. SKIN:
RINSE OFF WITH COPIOUS QTY OF WATER. EYES: RINSE FOR AT LST 15 MIN
FOLLOWING OVEREXP. INGEST: PHYS SHOULD BE CONTACTED. INGEST: A PHYS
SHOULD BE CONTACTED. KEEP WARM AND WATCH FOR SIGNS OF UNCON.
INHAL:GIVE ARTF RESP TO A PERSON WHO IS NOT BRTHG.
===================== Fire Fighting Measures =====================
Extinguishing Media:WILL NOT BURN. NO EXTINGUISHING MEDIA REQUIRED.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP SPILLED MATERIAL. PLACE IN A WASTE
DISPOSAL DRUM. WASH SPILL AREA WELL W/SOAP AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BRTHG OF DUST. DO NOT TAKE
INTERNALLY. AVOID CONT W/SKIN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR FITTED WITH
CARTRIDGE FOR FREE AMMONIA IS RECOMMENDED.
Ventilation:LOCAL EXHAUST IS HELPFUL.
Other Protective Equipment:LONG SLEEVED SHIRT AND PANTS, BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MP: 365F,185C(DECOMP).
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:SUPP DATA
Spec Gravity:1.435
Solubility in Water:6.4 G/100ML
Appearance and Odor:THIS MATERIAL IS A WHITE POWDER, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI CARBONATES, HYDROXIDES, ACETIC ANYDRIDE, POTASSIUM.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSITON PRODUCTS ARE NOT WELL
CHARACTERIZED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF THESE WASTE @ AN APPROVED TOXIC WASTE
DUMP. CONTACT YOUR STATE PESTICIDE OR ENVIRONMENTAL CONTRL AGENCY,
OR HAZ WASTE REPRESENTATIVE AT NEAREST EPA REGIONAL OFFICE FOR
FURTHER ASSISTANCE.DI SPOSE OF I/A/W FED, ST & LOC REGS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AMMONIA
CAGE:00742
CAGE:00742
============= Composition/Information on Ingredients =============
Ingred Name:ING 9:REGULATOR WHEN CONNECTING CYL TO LOWER PRESS (<500
PSIG) PIPING SYS. DO NOT HEAT CYL BY ANY MEANS TO (SEE ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 10:INCR DISCHARGE RATE FROM CYL. USE CHECK VALVE OR
TRAP IN DISCHARGE LINE TO PVNT HAZ BACK FLOW INTO (SEE ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:CYL. PROT CYLS FROM PHYS DMG. STORE IN
COOL/DRY/WELL-VENT AREA OF NON-COMBUST CONSTRUCTION AWAY FROM (SEE
ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:HEAVILY TRAVELED AREAS/EMER EXITS. DO NOT ALLOW TEMP
WHERE CYL ARE STORED TO EXCEED 125F. CYL SHOULD (SEE ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:BE STORED UPRIGHT/FIRMLY SECURED TO PREVENT FALLING
OR BEING KNOCKED OVER. FULL/EMPTY CYL SHOULD BE (SEE ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:SEGREGATED. USE "FIRST IN-FIRST OUT" INVENTORY
SYSTEM TO PREVENT FULL CYL BEING STORED FOR EXCESSIVE (SEE ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:PERIODS OF TIME.POST "NO SMKNG OR OPEN FLAMES" SIGNS
IN STOR/USE AREA. THERE SHOULD BE NO SOURCES OF (SEE ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:STOR/USE AREA. OTHER PREC:A COMPRESSED GAS CYL WHICH
HAS NOT BEEN FILLED BY OWNER/W/(WRITTEN)CONSENT (SEE ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:IS A VIOLATION OF FED LAW (49CFR). IN PRESENCE OF
TRACE AMTS OF H*2O, AMMONIA VIGOROUSLY ATTACKS CU,(SEE ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:SILVER, ZINC, & THEIR ALLOYS. IRON OR STEEL ARE
RECOMM FOR PACKAGING. KEEP AMMONIA SYSTEMS SCRUPULOUSLY DRY.
RTECS #:9999999ZZ
Ingred Name:AMMONIA (SARA III)
CAS:7664-41-7
RTECS #:BO0875000
Fraction by Wt: 100%
Other REC Limits:50 PPM PEL (MFR)
OSHA PEL:50 PPM
ACGIH TLV:25 PPM/35 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SUPP DATA:PULM EDEMA(EXCESS FLUID FORM IN LUNGS) WILL
RESULT. TOXIC LEVEL EXPOS TO SKIN CAUSES BURNS/SKIN (SEE ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:LESIONS RSLTING IN TISS DESTRUCT/SCARRING. BURNS
RESULT IN LESIONS/POSS LOSS OF VISION. FIRST AID PROC:(SEE ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:PERSONS W/POTNTL EXPOS SHOULD NOT WEAR CONTACT LESNES
SKIN:FLUSH AFFECTED AREA W/LGE QTYS OF WATER. (SEE ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:REMOVE AFFECTED CLOTHING AS RAPIDLY AS POSS. CONTINUE
FLUSHING W/WATER. SKIN CONTACT/FROSTBT:REMOVE (SEE INGRED 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:CONTAM CLTHNG/FLUSH AFFECTED AREA W/LUKEWARM WATER.
DO NOT USE HOT WATER. MD SHOULD SEE PROMPTLY IF (SEE ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:THE CRYOGENIC "BURN" HAS RSLTD IN BLISTERING OF SKIN
SURF/DEEP TISS FREEZING. WASTE DISP METH:TIGHTLY(SEE ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:CLSD, OUTLET SEALS SECURED/VALVE PROT CAP IN PLACE.
FOR EMER DISP ASSISTANCE, CALL "800" EMER # LISTED (SEE ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:HEREIN. HNDLG/STOR PREC:SLIDE ROLL CYLS. USE SUITABLE
HAND TRUCK FOR CYL MOVEMENT. USE PRESS REDUCING (SEE ING 10)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORROSIVE & IRRIT TO SKIN, EYES, UPPER
RESP SYS & ALL MUCOSAL TISSUE. DEPENDING ON CONCENTRATION INHALD,
IT MAY CAUSE BURNING SENSATIONS, COUGHING, WHEEZING, SHORTNESS OF
BREATH, HDCH, NAUS, WITH EVEN TUAL COLLAPSE. MILD CONCENTRATIONS OF
VAP WILL CAUSE DERM OR CONJUNCTIVITIS. HIGHER CONCENTRATIONS (SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:OF VAP OR LIQ CONTACT WILL CAUSE
CAUSTIC SKIN BURNS/INFLAMM/SWELL OF EYES W/POSS LOSS OF VISION.
RAPIDLY EVAPORATING LIQ CONTACTING SKIN OR EYES WILL CAUSE
CRYOGENIC "BURNS" OR FROSTBITE. SYM PS OF FROSTBITE INCL A CHANGE
IN SKIN COLOR TO GRAY/WHITE POSS FOLLOWED BY BLISTERING.
INHAL:AFFECTS UPPER(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:PROMPT MD ATTEN IS REQ IN ALL CASES OF OVEREXP TO
AMMONIA.INHAL:REMOVE TO UNCONTAM AREA. IF NOT BRTHNG, GIVE ARTF
RESP,PREF MOUTH-TO-MOUTH. IF BRTHNG DFCLT GIVE O*2. KEEP VICTIM
WARM/QUIET. ASSURE THA T MUCUS/VOMIT MATL DOES NOT OBSTRUCT AIRWAY
BY POSITIONAL DRAINAGE. GET MD IMMED. EYE:FLUSH CONTAM EYE(S) W/LGE
QTYS OF WATER FOR AT LEAST 15 MINS. HOLD EYELIDS OPEN TO ASSURE
COMPLETE (SEE INGRED 4)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:16%
Upper Limits:25%
Extinguishing Media:WATER.
Fire Fighting Procedures:IF POSS W/O RISK, STOP FLOW OF GAS. SINCE
AMMONIA IS SOLUBLE IN WATER, IT IS THE BEST EXTING MEDIA-NOT ONLY
EXTING FIRE, BUT ALSO ABSORBING ESCAPED (SUPP DATA)
Unusual Fire/Explosion Hazard:CYL EXPOSED TO FIRE/HEAT MAY VENT
RAPIDLY/EXPLODE. RUNOFF FROM FIRE CONTROL MAY CAUSE POLLUTION.
COMBINES W/MERCURY TO FORM EXPLO CMPDS. IS FLAMM OVER(SUPPDATA)
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL PERSONNEL FROM AFFECTED AREA. USE
APPROPRIATE PROT EQUIP IF LEAK IN USER'S EQUIP, PURGE PIPING
W/INERT GAS PRIOR TO ATTEMPTING REPAIRS. IF LEAK IS IN CNTNR OR
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN WELL-VENT AREAS. VALVE
PROT CAPS MUST REAMIN IN PLACE UNLESS CNTNR IS SECURED W/VALVE
OUTLET PIPED TO USE POINT. DO NOT DRAG(SEE INGRED 8)
Other Precautions:EARTH-GROUND & BOND ALL LINES/EQUIP ASSOCIATED
W/AMMONIA SYSTEM. ELEC EQUIP SHOULD BE NON-SPARKING OR EXPLO PROOF.
COMPRESSED GAS CYLINDERS SHOULD NOT BE REFILLED EXCEPT BY QUALIFIED
PRODUCERS OF COMP RESSED GAS. SHIPMENT OF (SEE INGRED 17)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED POSITIVE PRESSURE AIR LINE
W/MASK OR SCBA SHOULD BE AVAILABLE FOR USE.
Ventilation:HOOD WITH FORCED VENTILATION. LOCAL:TO PREVENT ACCUM ABOVE
TWA. MECH:I/A/W ELECTRICAL CODES.
Other Protective Equipment:SAFETY SHOES, SAFETY SHOWER, EYEWASH
"FOUNTAIN", CHEMICAL RESISTANT OVERGARMENTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:AMMONIA GAS. USE WATER SPRAY TO COOL SURROUND CNTNRS
UNTIL WELL AFTER FIRE IS OUT. USE NIOSH/MSHA SCBA & FULL PROTECTIVE
EQUIP. EFTS OF OVEREXP: AIRWAY (LARYNX/BRONCHI) BY CAUSING CAUS TIC
BURNING RESULTING IN ABNORMAL FLUIDFORMATION/CHEM PNEUMIT (DEEP
LUNG INFLAMM). IF ENTERS THE DEEP LUNG,(SEE ING 2)
================== Physical/Chemical Properties ==================
HCC:G1
Boiling Pt:B.P. Text:-28F,-33C
Vapor Pres:129.1 PSIA
Vapor Density:SEE ING 1
Solubility in Water:VERY SOL/LIBS HEAT
Appearance and Odor:COLORLESS GAS WITH A PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS VIGOROUSLY W/CHLORINE, FLUORINE, HYDROGEN BROMIDE, NITROSYL
CHLORIDE, CHROMYL CHLORIDE, TRIOXYGEN (SEE INGRED
Stability Condition to Avoid:ANY SYSTEM CONTAINING MERCURY.
Hazardous Decomposition Products:HYDROGEN AT VERY HIGH TEMPERATURES
(1544F).
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL FED, STATE & LOCAL REGS REGARDING
HEALTH/POLLUTION SHOULD BE FOLLOWED IN WASTE DISP. CONTACT AIR
PRODS FOR SPECIFIC RECOMMENDATIONS. DO NOT DISP OF UNUSED QTYS.
RETURN PROPERLY LABELED SHIPPING CN TNR TO AIR PRODS FOR DISP
W/VALVE(S) (SEE ING 7)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LIMESTONE
Kit Part:Y
CAGE:91224
CAGE:91224
CAGE:4T252
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9394
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXPOSURE MAY CAUSE EYE &
RESPIRATORY TRACT IRRITATION. EXCESSIVE ORAL DOSES MAY CAUSE
ALKALOSIS. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NO INGREDIENTS OF A CONCENTRATION OF
0.1% OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:EYES: BURNS, TEARING, PAIN, BLURRED VISION,
REDNESS. INHALED: COUGHING, SNEEZING.
Medical Cond Aggravated by Exposure:NONE REPORTED.
======================= First Aid Measures =======================
First Aid:EYE/SKIN CONTACT-IMMEDIATELY FLUSH EYES WITH WATER FOR 15
MINUTES. CALL PHYSICIAN. FLUSH SKIN WITH LOTS OF WATER. REMOVE
CONTAMINATED CLOTHES. INGESTED-IF CONSCIOUS, GIVE 1-2 GLASSES OF
WATER. DO NOT INDUCE VOMITING! CALL PHYSICIAN IMMEDIATELY.
INHALED: REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT APPLICABLE. DLA-HMIS: MEDIA APPROPRIATE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS:
FIREFIGHTERS SHOULD WEAR FULL PROTECTIVE CLOTHING INCLUDING
POSITIVE-PRESSURE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES OF CALCIUM OXIDE AND
CARBON DIOXIDE IN FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP SPILL. AVOID BREATHING MATERIAL.
DISSOLVE IN WATER. FLUSH DOWN DRAIN WITH EXCESS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TIGHTLY CLOSED IN A COOL, DRY
PLACE.
Other Precautions:AVOID CONTACT WITH EYES. WASH THOROUGHLY AFTER
HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF ENGINEERING CONTROLS
FAIL OR NON-ROUTINE USE OR EMERGENCY OCCURS; USE NIOSH/MSHA
APPROVED RESPIRATOR OR SUPPLIED AIR RESPIRATOR OR SCBA, AS
REQUIRED. USE IAW 29 CFR 1910.134 AND MANUFACTURER'S
RECOMMENDATIONS.
Ventilation:PROVIDE ADEQUATE VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS:
EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
KEY1=B3. CHANGE: 8745.
================== Physical/Chemical Properties ==================
HCC:C1
Melt/Freeze Pt:M.P/F.P Text:1517F,825C
Decomp Temp:Decomp Text:1517F,825C
Spec Gravity:2.711
Evaporation Rate & Reference:N/K (N-BUTYL ACETATE=1)
Solubility in Water:SLIGHT
Appearance and Odor:WHITE, ODORLESS POWDER.
Corrosion Rate:0.0 IPY
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS, FLUORINE, MAGNESIUM WITH HYDROGEN.
Stability Condition to Avoid:CONTACT WITH STRONG MINERAL ACIDS,
FLUORINE, MAGNESIUM WITH HYDROGEN.
Hazardous Decomposition Products:CALCIUM OXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:PHILLYCLAD 5066A HARDENER
Preparer's Name:ERNEST CARTER
CAGE:0SFY9
CAGE:0SFY9
============= Composition/Information on Ingredients =============
Ingred Name:TRIETHYLENETETRAMINE
CAS:112-24-3
RTECS #:YE6650000
< Wt:5.
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
< Wt:1.
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:DIMER/TOFA, REACTION PRODUCTS WITH TETA
CAS:68082-29-1
Code:F
> Wt:30.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Health Hazards Acute and Chronic:HAZARDS: SEVERE EYE, SKIN AND
RESPIRATORY TRACT IRRITANT (EVIDENCED BY RASH, BURNING SENSATION,
SORE THROAT, NAUSEA, SHORTNESS OF BREATH). HARMFUL IF ABSORBED
THROUGH SKIN. MAY CAUSE SKIN SENSITIZATIO N. AVOID BREATHING
VAPORS. USE WITH ADEQUATE VENTILATION. DO NOT TAKE INTERNALLY. WASH
THOROUGHLY AFTER HANDLING. DO NOT EXPOSE TO HEAT OR FLAMES.
Effects of Overexposure:SKIN: SEVERE IRRITANT. EYES: SEVERE IRRITANT.
INHALATION: IRRITATION OF NOSE AND THROAT, NAUSEA AND VOMITING IN
SEVERE CASES. INGESTION: MAY CAUSE IRRITATION OF MOUTH AND THROAT
AND GASTROINTESTINAL T RACT. REPEATED SKIN CONTACT CAN CAUSE
SENSITIZATION, WITH ITCHING, RASHES, OR SWELLING OF THE SKIN.
Medical Cond Aggravated by Exposure:EYE DISEASE,SKIN DISORDERS AND
ALLERGIES.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH WITH CLEAN WATER FOR AT LEAST 15
MINUTES WHILE GENTLY HOLDING EYELIDS OPEN. SKIN: WASH WELL WITH
SOAP AND WARM WATER. SEE A DOCTOR. INHALATION: REMOVE PATIENT TO
FRESH AIR. GIVE OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED. SEE
DOCTOR. INGESTION: DO NOT INDUCE VOMITING. DILUTE WITH LOTS OF MILK
OR WATER AND GET IMMEDIATE MEDICAL HELP.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=93.3C, 200.F
Extinguishing Media:WATER CARBON DIOXIDE DRY CHEMICAL.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR SELF CONTAINED
BREATHING APPARATUS AND SUFFICIENT PROTECTIVE GEAR TO PREVENT ALL
SKIN AND EYE CONTACT WITH THIS MATERIAL.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FOR LARGE SPILLS, PUMP TO STORAGE/SALVAGE
VESSELS. SOAK UP RESIDUE WITH AN ABSORBENT SUCH AS CLAY, SAND, OR
OTHER SUITABLE MATERIAL AND DISPOSE OF PROPERLY. FLUSH AREA WITH
WATER TO REMOVE TRACE RESID UE.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN, EYES, OR
CLOTHING. WASH THOROUGHLY WITH SOAP AND WATER AFTER HANDLE MIXED
RESIN HARDENER IN ACCORDANCE WITH THE POTENTIAL HAZARD OF THE
CURING AGENT . STORE IN A COOL, DRY ARE A.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED IN NORMAL USE WITH PROPER
VENTILATION. IN POORLY VENTILATED AREAS OR WHEN CREATING A DUST OR
MIST, USE NIOSH APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:GENERAL MECHANICAL VENTILATION IS ADEQUATE FOR OCCASIONAL
USE. FOR PROLONGED OR REPEATED USE, LOCAL EXHAUST IS RECOMMENDED.
Other Protective Equipment:NONE
Work Hygienic Practices:NONE
Supplemental Safety and Health
HAVE EMERGENCY SHOWER AND EYE WAH STATIONS AVAILABLE.
================== Physical/Chemical Properties ==================
Boiling Pt:=232.2C, 450.F
Vapor Pres:(MMHG): <0.01 AT 68 F
Vapor Density:AIR=1 >1
Spec Gravity:1-1.5
pH:ALKALINE
Evaporation Rate & Reference:(BUTYL ACETATE=1): <<1
================= Stability and Reactivity Data =================
STRONG OXIDIZERS, ACIDS, CHLORINATED ORGANIC COMPOUNDS.
Stability Condition to Avoid:EXTREME HEAT OR OPEN FLAME.
Hazardous Decomposition Products:FIRE: ACRID AND TOXIC FUMES WITH
ORGANIC AMINES, AMMONIA, OXIDES OF CARBON AND NITROGEN.
Conditions to Avoid Polymerization:HEAT IS RELEASED WHEN THIS PRODUCT
IS MIXED WITH EPOXY RESINS; USE CARE WHEN MIXING LARGE QUANTITIES.
=================== Toxicological Information===================
Toxicological Information:NOT PROVIDED.
===================== Ecological Information =====================
Ecological:NOT PROVIDED.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF THIS MATERIAL BECOMES A WASTE, IT WOULD NOT
BE A HAZARDOUS WASTE BY RCRA CRITERIA (40CFR 261). DISPOSE OF
ACCORDING TO APPLICABLE FEDERAL, STATE, AND LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:COMPOUNDS, CLEANING LIQUID
===================== Regulatory Information =====================
Federal Regulatory Information:ALL INGREDIENTS OF THIS PRODUCT ARE
LISTED, OR ARE EXEMPT FROM LISTING, ON THE TSCA INVENTORY.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HALON 1211,FOREX 1211
Preparer's Name:ENV.AFFAIRS COMMITTEE
CAGE:86460
CAGE:86460
============= Composition/Information on Ingredients =============
Ingred Name:BROMOCHLORDIFLUOROMETHANE (HALON 1211) (SARA III)
CAS:353-59-3
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:INHAL LD50 (RAT) IS 20PPH/15MIN
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:LIQUID CAN CAUSE
BURNS.SKIN:LIQUID CAN CAUSE FROSTBITE.INGEST:MAY CAUSE CNS
DEPRESSION.INHAL:CONCENTRATIONS ABOVE 20,000PPM MAY CAUSE HEART
ARRYTHMIAS AND CNS DEPRESSION.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:BELOW 10%, FEELING OF MILD INTOXICATION. ABOVE
10%, MAY LEAD TO UNCONSCIOUSNESS AND POSSIBLY DEATH.
Medical Cond Aggravated by Exposure:PERSONS WITH ANEMIA,ASTHMADERMAL
SENSITIVITY OR LOW BLOOD PRESSURE MAY BE AT INCREASED RISK FROM
EXPOSURE.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH WATER.EYES:FLUSH
WITH WATER FOR 15 MINUTES.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN OR
ARTIFICIAL RESPIRATION IF NEEDED.INGEST:GET PROMPT QUALIFIED
MEDICAL ATT ENTION.IF CONSCIOUS,INDUCE VOMITING WITH SYRUP OF
IPECAC.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NON-FLAMMABLE. USE EXTINGUISHING MEDIA APPROPIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:FIRE CONDITIONS MAY EVOLVE TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION,VENTILATE AREA.SOAK
UP REMAINING MATERIAL ON A NON-COMBUSTIBLE ABSORBANT;PLACE WASTE IN
A PROPER CONTAINER FOR DISPOSAL.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, WELL VENTILATED AREA.
KEEP AWAY FROM HEAT AND OPEN FLAMES. AVOID CONTAINER DAMAGE.
Other Precautions:DETERMINE THAT PIPING IS EMPTY BEFORE DOING
MAINTENANCE WORK.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS IF EXPOSED TO CONCENTRATIONS GREATER THAN 10%.
Ventilation:MECHANICAL (GENERAL) VENTILATION.
Other Protective Equipment:NONE
Work Hygienic Practices:USE REASONABLE CARE IN HANDLING THIS
PRODUCT.WASH HANDS AFTER USE AND BEFORE EATING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:24.8F,-4.0C
Melt/Freeze Pt:M.P/F.P Text:-256F,-160C
Vapor Pres:1758
Vapor Density:6.0
Spec Gravity:1.82
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GAS;COLORLESS;ETHEREAL ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALINE EARTH METALS,ALKALI,POWDERED ALUMINUM,ZINC,BERYLLIUM.
Stability Condition to Avoid:HIGH HEAT(ABOVE 850F), OPEN FLAMES.
Hazardous Decomposition Products:HYDROBROMIC, HYDROCHLORIC, AND
HYDROFLUORIC ACIDS, POSSIBLE FREE HALIDES AND CARBONYL HALIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CC-27L ALGICIDE
CAGE:FO796
CAGE:4S399
CAGE:FO796
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM DIMETHYLDITHIOCARBAMATE
CAS:128-03-0
RTECS #:FA0850000
Fraction by Wt: 10%
Ingred Name:INERT INGREDIENTS (TYPE NOT SPECIFIED)
Fraction by Wt: 90%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. INHALATION:
IRRITATION TO LUNG TISSUE DUE TO CORROSIVE CHARACTERISTICS. EYES:
CORROSIVE, IRRITATION/DAMAGE. INGESTION: HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION. INHALATION: IRRITATION TO
LUNG TISSUE DUE TO CORROSIVE CHARACTERISTICS. EYES: CORROSIVE,
IRRITATION & DAMAGE. INGESTION: HARMFUL.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/WATER FOR AT LEAST
15 MINS. INHALATION: REMOVE TO FRESH AIR; ADMINISTER OXYGEN.
INGESTION: IF CONSCIOUS, INDUCE VOMITING. NEVER INDUCE VOMITING OR
GIVE ANYTHIN G BY MOUTH TO AN UNCONSCIOUS PERSON. NOTE TO
PHYSICIAN: PROBABLE MUCOSAL DAMAGE MAY CONTRAINDICATE GASTRIC
LAVAGE. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>212F
Extinguishing Media:DRY CHEMICAL, WATER FOG, FOAM, CO2
================== Accidental Release Measures ==================
Spill Release Procedures:INITIALLY MINIMIZE AREA EFFECTED BY THE SPILL
OR LEAK. BLOCK ANY POTENTIAL ROUTES TO WATER SYSTEMS, SEWERS,
STREAMS, LAKE, ETC. RECOVER AS MUCH OF THE PURE PRODUCT AS
POSSIBLE. CLEAN-UP CONTAMINATED E NVIRONMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T CONTAMINATE WATER, FOOD, FEED BY
STORAGE OR DISPOSAL. DON'T EXPOSE TO EXTREME TEMPS. DON'T STACK
MORE THAN FOUR DRUMS HIGH.
Other Precautions:SPILLS SHOULD BE ABSORBED IN SAWDUST OR SAND &
DISPOSED OF IN A SANITARY LANDFILL. KEEP CONTAINER CLOSED WHEN NOT
IN USE. AVOID CONTACT W/SKIN, EYES, CLOTHING/CONTAMINATION OF FOOD.
KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT NECESSARY
Other Protective Equipment:RUBBER APRON, SHOES, EYE-WASH
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE. WASH
THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
THIS PESTICIDE IS TOXIC TO FISH. DON'T DISCHARGE TREATED EFFLUENT INTO
LAKES, STREAM, PONDS, OR PUBLIC WATERS UNLESS IN ACCORDANCE W/A
NPDES PERMIT. THIS PRODUCT CONTAINS 0.87 LB. OF ACTIVE INGREDIENT
PER GALLON/WEIGHS 8.68 LB. PER GALLON.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Spec Gravity:1.0-1.1
pH:12.3
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, GREEN LIQUID W/AMMONIA-SULFIDE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Hazardous Decomposition Products:CARBON DISULFIDE, DIMETHYLAMINE
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW FEDERAL, STATE, & LOCAL REGULATIONS
GOVERNING THE DISPOSAL OF WASTE MATERIALS. EPA REG. 8637-15
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:I-125 ISOJEX REFERENCE STANDARD
CAGE:FO650
CAGE:2A916
CAGE:FO650
============= Composition/Information on Ingredients =============
Ingred Name:ING 17: HEAVIER SHIELDING. AVOID CONTACT W/THE RADIOACTIVE
CONTENTS WHICH WOULD CAUSE UNNECESSARY EXPOSURE TO RADIATION.
RTECS #:9999999ZZ
Ingred Name:POTASSIUM IODIDE
CAS:7681-11-0
RTECS #:TT2975000
Fraction by Wt: 0.14%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >98.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OTHER PREC:APPROP TO GOVT AGENCY AUTHORIZED TO LISCENSE USE
OF RADIONCLIDE. THE VIAL CNTNG DRUG SHOULD BE KEPT (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:WITHIN ITS CNTNR OR WITHIN HVR SHIELDING. AVOID CONT
W/RADIOACTIVE CONTENTS WHICH WOULD CAUSE UNNEC EXPOS (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:TO RADIA. RADIOACTIVE MATLS ARE SUBSTANCES KNOWN TO
ST OF CA TO CAUSE REPROD TOX. UNDER PROP 65, FOLLOWING (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:WARNING APPLIES:WARNING:THIS PROD CNTNS SUBSTANCE
KNOWN TO STATE OF CALIFORNIA TO CAUSE REPRODUCTIVE TOXICITY.
RTECS #:9999999ZZ
Ingred Name:ING 9: W/WATER FOR AT LEAST 15 MIN OR UNTIL NO MORE
RADIOACTIVITY CAN BE REMOVED. NOTIFY RADIATION SAFETY PERSONNEL.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: PROCEDURES (SOPS) ESTABLISHED FOR YOUR FACILITY
& BY THE NRC OR OTHER APPLIC LOCAL, STATE OR FEDERAL REGS.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: IF MEDICAL WASTE IS INVOLVED, SUCH AS
BLOOD, BLOOD PRODS OR SHARPS, THE WASTE MUST BE HANDLED (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: AS A BIOHAZARD & DISPOSED OF ACCORDINGLY. IF NOT
RADIOACTIVE OR BIOHAZARD, WASTE ISOJEX REFERENCE (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: STANDARDS ARE CONSIDERED NON-HAZARDOUS. CONSULT
LOCAL, STATE & FEDERAL REGULATIONS FOR PROPER DISPOSAL.
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR PRECS:SHOULD BE USED. STORAGE & DISP OF PROD
SHOULD BE CONTROLLED IN A MANNER WHICH IS IN COMPLIANCE (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: W/APPROP REGS OF FEDERAL OR STATE GOVT AGENCY
AUTHORIZED TO LICENSE THE USE OF THIS RADIONUCLIDE.
RTECS #:9999999ZZ
Ingred Name:OTHER PRECS: THE USE OF THIS RADIONUCLIDE. THE VIAL
CONTAINING THE DRUG SHOULD BE KEPT W/IN ITS CNTNR OR W/IN (ING 18)
RTECS #:9999999ZZ
Ingred Name:RADIOACTIVE IODINE; (AQUEOUS SODIUM IODIDE I-125) SPEC
GRAV:17.4 MCI/UG OF IODINE ON CALIBRATION DATE.
CAS:9048-46-8
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM HYDROXIDE (CERCLA)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 0.07%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 0.20%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:VERY SMALL FRACTION
OF IODINATED ALBUMIN COULD BREAK DOWN & EMIT RADIOACTIVE FUMES
CONTAINING I-125. INGESTION:MAY CAUSE ASYMPTOMATIC PHYSIOLOGICAL
UPTAKE BY THYROID GLAND OR OTHER TI SSUES. EYE:NO ADVERSE EFFECT
EXPECTED, BUT MAY CAUSE MECHANICAL IRRITATION. CHRONIC:HEALTH RISKS
ASSOC (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:WITH CHRONIC RADIATION EXPOSURE
(CANCER, LEUKEMIA, GENETIC AND TERATOGENIC EFFECTS) ARE BELIEVED TO
INVOLVE LEVELS OF RADIATION EXPOSURE WHICH ARE MUCH HIGHER THAN
THOSE PERMITTED OCCUPATIONA LLY.
Medical Cond Aggravated by Exposure:NO INFORMATION FOUND.
======================= First Aid Measures =======================
First Aid:REMOVE PROMPTLY ANY CONTAM FROM SKIN, EYES/CLTHG.
INHAL:REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF RESP) .
INGEST:NOTIFY RADIA SFTY PERS IMMED. AMT OF I-125 IN THYROID GLAND
SHOULD BE ASS ESSED & DOCUMENTED. THYROID BLOCKING AGENT MAY BE
WARRANTED & ADMIN UNDER DIRECTION OF PHYS. SKIN:WASH AFFECTED AREA
THORO W/SOAP & WATER UNTIL NO MORE RADIOACTIVITY CAN BE REMOVED.
ALWAYS (SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:USE ANY MEANS SUITABLE FOR EXTINGUISHING
SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT CONSIDERED TO BE AN EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:IF PROD IS RECEIVED IN LEAKING CNDTN/ANY LOSS
OR RELEASE OF RADIOACTIVE CONTENTS OCCURS, NOTIFY YOUR RADIATION
SFTY DEPARTMENT & MALLINCKRODT @ (314)344-3800. ALL CLEANUP
OPERATIONS SHOULD BE PERFORME D ACCORDING TO STD OPERATING
PROC(SOPS)(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE @ 15C-30C. HNDLG TIME SHOULD BE
KEPT TO MIN & APPROP SHIELDING SHOULD BE USED. HNDLG DEVICES SUCH
AS SYRINGE SHIELDS & TONGS SHOULD BE USED.
Other Precautions:STOR & DISP OF PROD SHOULD BE CONTROLLED IN MANNER
WHICH IS IN COMPLIANCE W/APPROP REGS OF FED/ST GOVT AGENCY
AUTHORIZED TO LICENSE USE OF RADIONUCLIDE. CAUTION!RADIOACTIVE
DRUGS MUST BE HNDLD BY QUAL IFIED PERS IN CONFORMITY W/REGS (ING 6)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT EXPECTED TO REQ PERSONAL RESP USAGE.
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN
.
Ventilation:PROPERLY SEALED CONTAINERS ARE NOT EXPECTED TO REQUIRE ANY
SPECIAL VENTILATION.
Other Protective Equipment:LABCOAT. ANSI APPRVD EMERGENCY EYE WASH &
DELUGE SHOWER .
Work Hygienic Practices:NO SMKNG, EATING/DRINKING SHOULD BE ALLOWED IN
ANY AREA WHERE RADIOACTIVE MATLS ARE HANDLED OR STORED.
Supplemental Safety and Health
FIRST AID PROC:BLOT DRY. DO NOT ABRADE SKIN. EYES:WASH W/WATER FOR @
LEAST 15 MINUTES OR UNTIL NO MORE RADIOACTIVITY CAN BE REMOVED.
NOTIFY RADIATION SFTY PERS. SPILL RELEASE PROC:ESTABLISHED FOR YOUR
FACILITY. RADIOACTIVE WASTE SHOULD BE DISPOSED OF ACCORDING TO
SOPS ESTABLISHED BY YOUR RADIATION SAFETY OFFICER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Spec Gravity:SEE ING 1
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID IN A 4 ML GLASS SCREW-CAP
VIAL, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:STABLE UNDER ORDINARY CONDITIONS OF USE
AND STORAGE.
Hazardous Decomposition Products:MAY EMIT RADIOACTIVE FUMES CONTAINING
I-125 WHEN HEATED TO DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:ENSURE COMPLIANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:40/60
CAGE:FO309
CAGE:FO309
CAGE:27911
============= Composition/Information on Ingredients =============
Ingred Name:TIN (AS SN)
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 40%
OSHA PEL:2 MG/CUM
ACGIH TLV:2.0 MG/CUM
Ingred Name:LEAD, INORGANIC LEAD (SUSPECTED HUMAN CARCINOGEN BY IARC,
NTP & ACGIH)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 60%
ACGIH TLV:0.15 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ZINC CHLORIDE
CAS:7646-85-7
RTECS #:ZH1400000
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ROSIN CORE SOLDER PYROLYSIS PRODUCTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEVERE OVEREXPOSURE CAN CAUSE
PULMONARY EDEMA. PROLONGED INHALATION EXPOSURE MAY CAUSE
LUNG/KIDNEY DAMAGE. FUMES FROM ACID & ROSIN CORE CAN IRRITATE THE
NOSE & THROAT. ZINC CHLORIDE IN ACID CORE SOLDE R MAY IRRITATE THE
SKIN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, NAUSEA, DIZZINESS, BODY
ACHES, ANEMIA, CHEST PAINS, COUGH, FEVER, SHORTNESS OF BREATH.
Medical Cond Aggravated by Exposure:IMPAIRED PULMONARY FUNCTION
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED
PERFORM CPR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Unusual Fire/Explosion Hazard:NONFLAMMABLE. OPEN FLAMES & SPARKS CAN
IGNITE COMBUSTIBLES.
======================Handling and Storage ======================
Handling and Storage Precautions:WASH HANDS THOROUGHLY BEFORE SMOKING
OR EATING & AFTER USING LEAD BEARING SOLDERS. TRAIN EMPLOYEE TO
KEEP HEAD OUT OF THE FUMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN SOLDERING IN CONFINED AREAS.
Ventilation:LOCAL EXHAUST AT THE FLAME TO KEEP THE FUMES & GASES BELOW
TLVS.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING, APRONS, HATS,
SHOULDER PROTECTION, FACE SHIELD IF FILTER LENS OF APPROPRIATE
SHADES, SCREENS.
Work Hygienic Practices:WASH HANDS THOROUGHLY BEFORE SMOKING OR EATING
& AFTER USING LEAD BEARING SOLDERS.
Supplemental Safety and Health
WEAR DARK SUBSTANTIAL CLOTHING. SOLDER FUMES CAN'T BE CLASSIFIED
SIMPLY. THE COMPOSITION & QUALITY ARE DEPENDANT UPON METAL BEING
SOLDERED, THE PROCESS, PROCEDURES & FILTER METALS USED, COATINGS,
NUMB ER OF OPERATORS, VOLUME OF WORK AREA & CONTAMINANTS IN THE
ATMOSPHERE.
================== Physical/Chemical Properties ==================
Appearance and Odor:WIRE, SOLID GREY TO SILVER IN COLOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ZINC CHLORIDE: CYANIDES, SULFIDES,
Hazardous Decomposition Products:SOLDERING FUMES, ZINC CHLORIDE:
HYDROGEN CYANIDE GAS, HYDROGEN SULFIDE GAS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TASK FORCE
CAGE:58396
Contract Num:SP0450-01-M-ZG25
CAGE:58396
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: TO 100%
Ingred Name:GLYCOL ETHER
CAS:25498-49-1
RTECS #:UB8070000
Minumum % Wt:0.
Maxumum % Wt:5.
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:POTASSIUM HYDROXIDE
CAS:1310-58-3
RTECS #:TT2100000
= Wt:2.5
ACGIH TLV:C 2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NONIONIC SURFACTANT
CAS:9016-45-9
RTECS #:AX0247000
Minumum % Wt:0.
Maxumum % Wt:5.
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
Minumum % Wt:0.
Maxumum % Wt:5.
Ingred Name:DYE
< Wt:.01
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITANT. MAY CAUSE MODERATE
REDDENING AND SWELLING. EYES: IRRITANT. LIQUID AND MISTS MAY DAMAGE
EYES CAUSING CORNEAL DAMAGE. INHALATION: VAPORS AND MISTS MAY BE
IRRITATING TO MUCOUS MEMBRANES I N THE NOSE, THROAT, AND LUNGS.
INGESTION: IRRITATING, AND CORROSIVE TO THE MOUTH AND THROAT. MAY
CAUSE HEADACHE, NAUSEA, ABDOMINAL PAIN, VOMITING, AND DIARRHEA.
EXCESSIVE AMOUNTS MAY CAUSE COLLAPSE.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED AS A CARCINOGEN.
Effects of Overexposure:SKIN: IRRITATION, MODERATE REDDENING, AND
SWELLING. EYES: IRRITATION, EYE DAMAGE, CORNEAL DAMAGE. INHALATION:
VAPORS AND MISTS MAY BE IRRITATING TO MUCOUS MEMBRANES IN THE NOSE,
THROAT AND LUNGS. INGE STION: IRRITATION, AND CORROSIVE TO THE
MOUTH AND THROAT. MAY CAUSE HEADACHE, NAUSEA, ABDOMINAL PAIN,
VOMITING, AND DIARRHEA. EXCESSIVE AMOUNTS MAY CAUSE COLLAPSE.
======================= First Aid Measures =======================
First Aid:SKIN: FLUSH WITH WATER. SEEK MEDICAL ATTENTION IF IRRITATION
PERSISTS. EYES: FLUSH WITH LARGE QUANTITIES OF WATER, HOLDING
EYELIDS OPEN. SEEK MEDICAL ATTENTION IF IRRITATION PERSISTS.
INHALATION: GET TO FRESH AIR. SEEK MEDICAL ATTENTION IF IRRITATION
PERSISTS. INGESTION: DO NOT INDUCE VOMITING. DRINK LARGE QUANTITIES
OF WATER. SEEK MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:NON FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP OR OTHERWISE ABSORB AND HOLD FOR
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN, AND
CLOTHING. KEEP OUT OF REACH OF CHILDREN. FOR USE BY TRAINED
PERSONNEL ONLY. KEEP CONTAINER CLOSED DURING STORAGE. FOR
INSTITUTIONAL AND INDUSTRIAL USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE IN WELL VENTILATED AREA.
Ventilation:PROVIDE LOCAL EXHAUST TO KEEP TLV BELOW ACCEPTABLE LIMIT.
Other Protective Equipment:EYEWASH STATION, CHEMICAL RESISTANT APRON.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:=98.9C, 210.F
Vapor Pres:20 MM HG @ 68F
Vapor Density:>1(AIR=1)
Spec Gravity:1.042
pH:13.0-13.5
Evaporation Rate & Reference:<1 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:THIN GREEN LIQUID WITH CHARACTERISTIC ODOR.
Percent Volatiles by Volume:75%+
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Hazardous Decomposition Products:ALKALINE VAPORS IN A FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:ANY METHOD IN ACCORDANCE WITH APPLICABLE LAWS.
=================== MSDS Transport Information ===================
Transport Information:COMPOUNDS. CLEANING LIQUID, (POTASSIUM HYDROXIDE,
SOLUTION), 8, NA 1760, PG I I I.
===================== Regulatory Information =====================
SARA Title III Information:NONE OF THE INGREDIENTS IN THIS PRODUCT IS
SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF THE
EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1986 AND OF
40 CFR 372.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SODIUM THIOSULFATE, SOLUTION REAGENT
CAGE:3D869
CAGE:3D869
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM THIOSULFATE
CAS:7772-98-7
RTECS #:XN6476000
Fraction by Wt: 19.8%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 71.2%
===================== Hazards Identification =====================
Effects of Overexposure:LARGE DOSES OF SOLID INGESTED ACTS AS
CATHARTIC.EYE/SKIN CONTACT:IRRITANT
======================= First Aid Measures =======================
First Aid:EYE/SKIN:FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL PHYSICIAN
IF EYE CONTACT.
===================== Fire Fighting Measures =====================
Extinguishing Media:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH APPROPRIATE MATERIAL AND PLACE IN
APPROVED CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:AS NEEDED.
Other Protective Equipment:AS NEEDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F
Spec Gravity:1.729
Solubility in Water:COMPLETE
Appearance and Odor:WHITE ODORLESS CRYSTALS DISSOLVED IN WATER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ABSORB MATERIAL AS SOLID WASTE IN
ACCORDANCE WITH FEDERAL,STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:4400-0101 DENATURATION REAGENT
Kit Part:Y
CAGE:GO641
CAGE:015J7
CAGE:GO641
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE, CAUSTIC SODA, LYE * 96-3 *
CAS:1310-73-2
RTECS #:WB4900000
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/CUM
ACGIH TLV:2 MG/CUM CEILING
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SODIUM HYDROXIDE: POISON BY INGESTION
& INTRAPERITONEAL ROUTE. MUTAGENIC. CORROSIVE & IRRITANT TO SKIN,
EYES & MUCOUS MEMBRANES.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/COPIOUS QUANTITIES OF WATER FOR 15 MINS.
INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN, CPR IF NECESSARY.
SKIN: FLUSH W/COPIOUS QUANTITIES OF WATER FOR 15 MINS. INGESTION:
DON'T INDUCE VO MITING. IF CONSCIOUS, GIVE LARGE AMOUNTS OF WATER.
FOLLOW W/DILUTED VINEGAR, FRUIT JUICE/WHITES OF EGGS, BEATEN
W/WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE TO SURROUNDING
FIRE CONDITIONS.
Fire Fighting Procedures:USE SELF CONTAINED BREATHING APPARATUS & WEAR
PROTECTIVE CLOTHING TO PREVENT CONTACT W/EYES & SKIN.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
NEUTRALIZE W/APPROPRIATE NEUTRALIZER. COVER W/SAND/OTHER
NONCOMBUSTIBLE ABSORBENT MATERIAL, TAKE UP & DISPOSE OF. FLUSH AREA
W/FLOODING AMOUNTS OF WATER. DON'T FLUSH TO THE SEWER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:REQUIRED
Other Protective Equipment:SAFETY SHOWER, SUITABLE PROTECTIVE CLOTHING,
EYEWASH
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
INCOMPATIBILITY CONT'D: METALS SUCH AS ALUMINUM, TIN & ZINC TO FORM
FLAMMABLE HYDROGEN GAS.
================== Physical/Chemical Properties ==================
Spec Gravity:1.01
Solubility in Water:MISCIBLE
Appearance and Odor:A CLEAR COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ACIDS, FLAMMABLE LIQUIDS, ORGANIC HALOGEN COMPOUNDS,
TRICHLOROETHYLENE, NITROMETHANE/NITRO COMPOUNDS, (SEE SUPP)
Hazardous Decomposition Products:SHOCK SENSITIVE SALTS, HYDROGEN GAS,
SODIUM OXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL SPEC. POUR (A COMPONENT)
Kit Part:Y
Preparer's Name:M ORTEGA
CAGE:46088
CAGE:46088
============= Composition/Information on Ingredients =============
Ingred Name:DIPHENYLMETHANEDIISOCYANATE (MDI), METHYLENE BIS
(PHENYLISOCYANATE), 4,4 DIPHENYLMETHANE DIISOCYANATE (MDI)
CAS:101-68-8
RTECS #:NQ9350000
Fraction by Wt: 30-60%
Other REC Limits:0.005 PPM
OSHA PEL:0.02 PPM
ACGIH TLV:0.051 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:HIGHER OLIGOMERS OF MDI, POLYMETHYLENE POLYPHENYLENE
POLYISOCYANATE
CAS:9016-87-9
RTECS #:TR0350000
Fraction by Wt: 30-60%
Ingred Name:FLAME RETARDANT
Fraction by Wt: 10-30%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: IRRITATION &
MAY CAUSE SENSITIZATION. INHALATION: IRRITATING TO RESPIRATORY
TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, COUGHING, WHEEZING, SHORTNESS OF
BREATH.
Medical Cond Aggravated by Exposure:INDIVIDUALS W/ASTHMA, ECZEMA
&/ALLERGIES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/CLEAN, LOW PRESSURE WATER FOR 15 MINS. SKIN:
WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION:
GIVE LARGE AMOUNTS OF LIQUIDS, DON'T INDUCE VOMITING. OBTAIN
MEDICAL ATTENTI ON IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:425F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER
Fire Fighting Procedures:USE SCBA.
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE ADEQUATE VENTILATION. WEAR SUITABLE
PERSONAL PROTECTIVE CLOTHING & EQUIPMENT. CONTAIN & COLLECT USING
SUITABLE ABSORBENT MATERIAL, SAWDUST/VERMICULITE. SHOVEL INTO WASTE
CONTAINER ADDING DECON TAMINATE SOLUTION. LEAVE UNCOVERED FOR 24
HOURS.
Neutralizing Agent:DECONTAMINATE SOLUTION: 90% WATER, 7% AMMONIA & 3%
DETERGENT.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT CONTAINERS FROM PHYSICAL
ABUSE. AVOID DIRECT SUNLIGHT. STORE AT TEMP 60-90F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR EXCEEDING THE TLV, WEAR SCBA.
Ventilation:USE ONLY IN WELL VENTILATED AREAS W/INSUFFICIENT
VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:<0.00001
Spec Gravity:1.2
Appearance and Odor:DARK BROWN LIQUID W/A MUSTY ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ALKALIES, ACIDS, ALCOHOL, AMMONIA, REACTION MAY BE VIOLENT AT
ELEVATED TEMPS, AMINES & METAL COMPOUNDS.
Stability Condition to Avoid:DIRECT SUNLIGHT
Hazardous Decomposition Products:DURING COMBUSTION: CO, CO2, NITROGEN
OXIDES, AMMONIA & TRACE AMOUNTS OF HYDROGEN CYANIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:REFILLABLE TANKS: DON'T PUNCTURE/INCINERATE.
RELIEVE PRESSURE <40 PSI BEFORE RETURNING EMPTY TANKS. DRUMS:
FOLLOW DRUM RECYCLING CHECKLIST & SHIPPING INSTRUCTIONS LOCATED ON
DRUM. DISPOSE OF IAW/FEDER AL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:4661 FORTIFY
CAGE:0U826
CAGE:0U826
CAGE:32204
============= Composition/Information on Ingredients =============
Ingred Name:ACRYLIC POLYMER
Fraction by Wt: 10-20%
Ingred Name:AMMONIUM HYDROXIDE, AQUA AMMONIA
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: 1-2%
Other REC Limits:25 PPM
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-((2-ETHYLHEXYL)OXY), ETHYLENE GLYCOL, 2-ETHYL HEXYL ETHER
CAS:1559-35-9
RTECS #:KK9625000
Fraction by Wt: 1-3%
Ingred Name:DIETHYLENE GLYCOL ETHYL ETHER, CARBITOL, CARBITOL
CELLOSOLVEETHOXY DIGLYCOL, 2-(2-ETHOXYETHOXY)-ETHANOL
CAS:111-90-0
RTECS #:KK8750000
Fraction by Wt: 1-3%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70-85%
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 0.17 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RATS): >5000 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE MILD IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/WATER FOR 20 MINS. SKIN: WASH
W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK
1-2 GLASSES OF WATER/MILK. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:NORMAL FIRE FIGHTING PROCEDURES MAY BE USED.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/OIL-DRI/SIMILAR INERT MATERIAL.
SWEEP/SCRAPE UP & CONTAINERIZE. CONTAINS AMMONIA. DON'T LET
MATERIAL ENTER WATERCOURSE. MAY BE TOXIC TO AQUATIC LIFE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE W/ADEQUATE
VENTILATION.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENTS UNDER NORMAL USE.
Ventilation:GENERAL ROOM VENTILATION ADEQUATE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH: 9.7-10.1.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Melt/Freeze Pt:M.P/F.P Text:32F
Vapor Pres:20-25
Spec Gravity:1.02
pH:(SUPP)
Evaporation Rate & Reference:(BU AC = 1): 0.3-0.5
Solubility in Water:COMPLETE
Appearance and Odor:OPAQUE OFF-WHITE LIQUID W/MILD AMMONIA LIKE ODOR.
Percent Volatiles by Volume:84-86
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NORMAL PRODUCTS OF COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:AMCHEM P/N 600
Preparer's Name:C A EISENHARD
CAGE:JO915
CAGE:60777
CAGE:JO915
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIC ACID
CAS:1333-82-0
RTECS #:GB6650000
Fraction by Wt: 30-40%
Other REC Limits:NONE SPECIFIED
OSHA PEL:.05 MG/M3 (AS CR)
ACGIH TLV:.05 MG/M3 (AS CR)
Ingred Name:SODIUM FLOUBORATE
CAS:13755-29-8
RTECS #:ED2975000
Fraction by Wt: 40-50%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2.5 MG/M3 (AS F)
ACGIH TLV:2.5 MG/M3 (AS F)
Ingred Name:POTASSIUM FLUOZIRCONATE (SARA III)
CAS:16923-95-8
RTECS #:TT0875000
Fraction by Wt: 10-15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (AS F)
ACGIH TLV:5 MG/M3 (AS F)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:EYE: VISION LOSS W/SEVERE BURNS. SKIN:
CORROSIVE TO TISSUE. INGEST: DIGESTIVE TRACT TISSUE DESTRUCTION &
SEVERE IRRITATION IN RESP SYSTEM. INHAL: MUCOUS MEMBRANE DAMAGE,
NASAL SEPTUM ULCERATION/PERFOR ATION & IRRIT OF RESP SYS. CHRONIC:
REPEAT SKIN CONTACT: CHROME SORES. LONG TERM EXPOS: LIVER, KIDNEY
DAMAGE. FLOUROSIS.
Explanation of Carcinogenicity:EVIDENCE THAT AQUEOUS SODIUM DICHROMATE
INCREASED INCIDENCE OF LUNG CANCER. CHROMIUM COMPOUND CARCINOGENIC
IN HUMANS.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF ASTHMA,
ALLERGIES OR KNOWN SENSITIZATION TO CHROMIC ACID OR CHROMATES.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH EYES WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15
MINS, SEEK MEDICAL ATTENTION. SKIN: WASH AREA WITH WATER FOR AT
LEAST 15 MINUTES. WASH CONTMAINATED CLOTHING. GET MEDICAL
ATTENTION. GET M EDICAL ATTENTION. INGESTION: DILUTE WITH LARGE
QUANTITIES OF WATER. DO NOT INDUCE VOMITING. SEEK IMMEDIATE MEDICAL
ATTENTION. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF NEEDED.
GET MEDICAL HELP.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER
Fire Fighting Procedures:WEAR POSITIVE PRESSURE SELF-CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VIOLENT REACTIONS MAY OCCUR WITH ORGANIC
MATERIALS OR REDUCING AGENTS.
================== Accidental Release Measures ==================
Spill Release Procedures:TRANSFER ANY EXCESS TO A CLEAN POLYETHYLENE
CONTAINER. TREAT REMAINING RESIDUE WITH A DILUTE SOLUTION OF SODIUM
METABISULFITE TO REDUCE CHROME.
Neutralizing Agent:NEUTRALIZE WITH LIME TO PH 7-8
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP SEPARATE FROM ORGANIC MATERIALS
AND REDUCING AGENTS. DO NOT BREATHE DUST OR GET IN EYES OR ON SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FILTER TYPE DUST RESPIRATOR--NIOSH APPROVED.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:RUBBER APRON
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:D3
Solubility in Water:APPRCIABLE
Appearance and Odor:YELLOW TO ORANGE POWDER CONTAINING REDDISH-BROWN.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ORGANIC MATERIALS, REDUCING AGENTS, ALKALINE MATERIALS.
Hazardous Decomposition Products:HYDROGEN FLUORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH REDUCE AND NEUTRALIZED MATERIAL TO
TREATMENT PLANT WITH PLENTY OF WATER AND WITH APPROVAL OF
REGULATORY AGENCY. HAZARDOUS WASTE # D001.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:123 7927, DEKTOL DEVELOPER (SINGLR POWDER)
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM PHOSPHATE, TRIBASIC(SARA III)
CAS:10124-56-8
RTECS #:OY3675000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:POTASSIUM BROMIDE
CAS:7758-02-3
RTECS #:TS7650000
Fraction by Wt: 11-5%
Other REC Limits:NONE SPECIFIED
Ingred Name:SODIUM CARBONATE
CAS:5968-11-6
Fraction by Wt: 50-55%
Other REC Limits:NONE SPECIFIED
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 30-35%
Other REC Limits:NONE SPECIFIED
Ingred Name:HYDROQUINONE (SARA III)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 6%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:P-METHYLAMINOPHENOL SULFATE (METOL)
CAS:55-55-1
RTECS #:SL8650000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50 IS 0.5-5.0 G/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT MAY CAUSE EYE, SKIN &
RESPIRATORY OR G/I TRACT IRRITATION. IT IS CONSIDERED A LOW HAZARD
FOR NORMAL INDUSTRIAL HANDLING.
Explanation of Carcinogenicity:IARC REPORTS HYDROQUINONE 'INSUFFICIENT
EVIDENCE TO CLASSIFY
Effects of Overexposure:EYE:CAUSES IRRITATION SKIN:CAUSES IRRITATION,
AND MAY SENSITIZE AN ALLERGIC REACTION. INHALED:UNLIKELY
EXPOSURE,INHALATION OF DUST MAY CAUSE IRRITATION. INGESTED:MAY BE
HARMFUL IF SWALLOWED. HMIS:M AY CAUSE G/I
IRRITATION,NAUSEA,VOMITING,PALLOR,TINNITIS,DIZZINESS, OR INCREASED
RESPIRATORY RATE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. WASH WITH SOAP &
WATER. INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING AS NEEDED.
INGESTED:IMMEDIA TELY GIVE 2 LARGE GLASSES OF MILK OR WATER AND
INDUCE VOMITING. (NOTHING BY MOUTH IF UNCONSCIOUS.) GET IMMEDIATE
MEDICAL CARE. IF ANY IRRITATION PERSISTS OR IS SEVERE, SEE A
DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:PRODUCT IS NON FLAMMABLE. EXTINGUISH FIRE WITH
MEDIA APPROPRIATE FOR SOURCE OF FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER AS LIQUID OR MOP UP WITH
CLOTH,PAPER,ETC.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL VENTILATED
AREA. KEEP TIGHTLY CLOSED WHEN NOT IN USE. KEEP AWAY FROM STRONG
ACIDS AND OXIDIZERS.
Other Precautions:READ LABEL AND FOLLOW DIRECTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR RESPIRATOR FOR
ALKALINE MIST IF EXPOSURE IS ABOVE THE TLV/PEL. SEE 29 CFR 1910.134
FOR REGULATIONS PERTAI NING TO RESPIRATOR USE.
Ventilation:NORMAL ROOM VENTILATION SUPPLEMENTED WITH LOCAL EXHAUST
ESPECIALLY WHEN MIXING.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. USE APRON
AND FACE SHIELD WHEN POURING LIQUIDS OR IF SPLASHING IS LIKELY.SEE
SUPP DATA
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT.
Supplemental Safety and Health
ROUTINE USE OF AN ACID TYPE HAND CLEANER WILL MINIMIZE POSSIBILITY OF
IRRITATION. SOLUTION NUMBER 224. ACCESSION NUMBER 354538.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:POWDER
Vapor Pres:NEGLIGIBLE
Vapor Density:NEGLIGIBLE
Spec Gravity:NOT RELAVANT
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE POWDER, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:NONE GIVEN BY MANUFACTURER (SUPPLIER).
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SULFUR DIOXIDE, NITROGEN OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
MFR SUGGESTS FLUSH TO ACID-FREE SEWER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BUTADIENE, INHIBITED
Kit Part:=== Responsible Party ===
780-471-4036
780-471-4036
CAGE:Company Name:MATHESON TRI-GAS, INC.
780-471-4036
CAGE:
============= Composition/Information on Ingredients =============
Ingred Name:BUTADIENE, INHIBITED
CAS:106-99-0
Fraction by Wt: >99.0%
Ingred Name:(1,1-DIMETHYLETHYL)-1,2-BENZENEDIOL
CAS:27213-78-1
Fraction by Wt: 0.1-0.2%
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:Yes IARC:Yes OSHA:Yes
Health Hazards Acute and Chronic:INHALATION: SHORT TERM EXPOSURE:
irritation, nausea, headache, drowsiness, symptoms of drunkenness
LONG TERM EXPOSURE: digestive disorders, kidney damage, liver
enlargement, reproductive effects, cancer SKIN CONTACT: SHORT TERM
EXPOSURE: blisters, frostbite LONG TERM EXPOSURE: no information on
significant adverse effects EYE CONTACT: SHORT TERM EXPOSURE:
irritation, blurred vision LONG TERM EXPOSURE: no information on
significant adverse effects INGESTION: SHORT TERM EXPOSURE:
frostbite LONG TERM EXPOSURE: no information on significant adverse
effects
Medical Cond Aggravated by Exposure:
======================= First Aid Measures =======================
First Aid: INHALATION: If adverse effects occur, remove to
uncontaminated area. Give artificial respiration if not breathing.
If breathing is difficult, oxygen should be administered by
qualified personnel. Get immediate medical attention. SKIN CONTACT:
If frostbite or freezing occur, immediately flush with plenty of
lukewarm water (105-115 F; 41-46 C). DO NOT USE HOT WATER. If warm
water is not available, gently wrap affected parts in blankets. Get
immediate medical attention. EYE CONTACT: Wash eyes immediately
with large amounts of water, occasionally lifting upper and lower
lids, until no evidence of chemical remains. Get medical attention
immediately. INGESTION: If a large amount is swallowed, get medical
attention. NOTE TO PHYSICIAN: For inhalation, consider oxygen.
===================== Fire Fighting Measures =====================
Flash Point:-105 F (-76 C)
Autoignition Temp:788 F (420 C)
Lower Limits:2.0%
Upper Limits:11.5%
Extinguishing Media:carbon dioxide, regular dry chemical Large fires:
Use regular foam or flood with fine water spray.
Fire Fighting Procedures:Move container from fire area if it can be
done without risk. For fires in cargo or storage area: Cool
containers with water from unmanned hose holder or monitor nozzles
until well after fire is out. If this is impossible then take the
following precautions: Keep unnecessary people away, isolate hazard
area and deny entry. Let the fire burn. Withdraw immediately in
case of rising sound from venting safety device or any
discoloration of tanks due to fire. For tank, rail car or tank
truck: Stop leak if possible without personal risk. Let burn unless
leak can be stopped immediately. For smaller tanks or cylinders,
extinguish and isolate from other flammables. Evacuation radius:
800 meters (1/2 mile). Stop flow of gas.
Unusual Fire/Explosion Hazard:Severe fire hazard. Vapor/air mixtures
are explosive. The vapor is heavier than air. Vapors or gases may
ignite at distant ignition sources and flash back.
================== Accidental Release Measures ==================
Neutralizing Agent:
======================Handling and Storage ======================
Handling and Storage Precautions:Store and handle in accordance with
all current regulations and standards. Grounding and bonding
required. Store outside or in a detached building. Secure to
prevent tipping. Store in a cool, dry place. Store in a
well-ventilated area. Avoid heat, flames, sparks and other sources
of ignition. Subject to storage regulations: U.S. OSHA 29 CFR
1910.101. See original container for storage recommendations. Keep
separated from incompatible substances.
Other Precautions:
============= Exposure Controls/Personal Protection =============
Respiratory Protection:The following respirators and maximum use
concentrations are drawn from NIOSH and/or OSHA. 5 ppm Any
air-purifying respirator with a full facepiece and a canister
providing protection against this substance. 10 ppm Any
air-purifying respirator with a full facepiece and a canister
providing protection against this substance. 25 ppm Any
air-purifying respirator with a full facepiece and a canister
providing protection against this substance. Any powered,
air-purifying respirator with a full facepiece and cartridge(s)
providing protection against this substance. Any supplied-air
respirator operated in a continuous-flow mode. 50 ppm Any
air-purifying respirator with a full facepiece and a canister
providing protection against this substance. Any powered,
air-purifying respirator with a full facepiece and cartridge(s)
providing protection against this substance. 1000 ppm Any
supplied-air respirator with full facepiece and operated in a
pressure-demand or other positive-pressure mode in combination with
a separate escape supply. Any air-purifying respirator with a full
facepiece and a canister providing protection against this
substance. For Unknown Concentrations or Immediately Dangerous to
Life or Health - Any self-contained breathing apparatus that has a
full facepiece and is operated in a pressure-demand or other
positive-pressure mode. Any supplied-air respirator with full
facepiece and operated in a pressure-demand or other
positive-pressure mode in combination with a separate escape
supply. Escape - Any self-contained breathing apparatus that has a
full facepiece and is operated in a pressure-demand or other
positive-pressure mode. Any air-purifying respirator with a full
facepiece and a canister providing protection against this
substance. For Unknown Concentrations or Immediately Dangerous to
Life or Health - Any supplied-air respirator with full facepiece
and operated in a pressure-demand or other positive-pressure mode
in combination with a separate escape supply. Any self-contained
breathing apparatus with a full facepiece.
Ventilation:Ventilation equipment should be explosion-resistant if
explosive concentrations of material are present. Provide local
exhaust or process enclosure ventilation system. Ensure compliance
with applicable exposure limits.
Contact lenses should not be worn. Provide an emergency eye wash
fountain and quick drench shower in the immediate work area.
Other Protective Equipment:For the gas: Protective clothing is not
required. For the liquid: Wear appropriate protective, cold
insulating clothing.
Supplemental Safety and Health
BUTADIENE, INHIBITED: 1,3-BUTADIENE: 1 ppm OSHA TWA 5 ppm OSHA STEL 15
minute(s) 0.5 ppm OSHA action level 2 ppm ACGIH TWA
================== Physical/Chemical Properties ==================
Boiling Pt:23 F (-5 C)
Melt/Freeze Pt:-164 F (-109 C)
Vapor Pres:910 mmHg @ 20 C
Vapor Density:1.87
Spec Gravity:0.6211 @ 20 C
pH:Not applicable
Evaporation Rate & Reference:>25 (butyl acetate=1)
Solubility in Water:0.05% @ 20 C
Appearance and Odor:PHYSICAL STATE:gas COLOR:colorless ODOR:distinct
odor
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:May polymerize. Avoid contact
with light or storage and use above room temperature. May explode
if exposed to shock, friction or heating.
Stability Condition to Avoid:Avoid heat, flames, sparks and other
sources of ignition. Containers may rupture or explode if exposed
to heat.
Hazardous Decomposition Products:Thermal decomposition products: oxides
of carbon Thermal decomposition products: oxides of carbon
Conditions to Avoid Polymerization:May polymerize. Avoid contact with
heat, air, light, initiators or curing agents. May polymerize with
evolution of heat. Closed containers may rupture violently.
=================== Toxicological Information===================
Toxicological Information:BUTADIENE, INHIBITED: TOXICITY DATA: 285
gm/m3/4 hour(s) inhalation-rat LC50; 5480 mg/kg oral-rat LD50
CARCINOGEN STATUS: OSHA: Carcinogen; NTP: Known Human Carcinogen;
IARC: Human Limited Evidence, Animal Sufficient Evidence, Group 2A;
ACGIH: A2 -Suspected Human Carcinogen; EC: Category 2 ACUTE
TOXICITY LEVEL: Slightly Toxic: ingestion Relatively Non-toxic:
inhalation TARGET ORGANS: central nervous system TUMORIGENIC DATA:
Available. MUTAGENIC DATA: Available. REPRODUCTIVE EFFECTS DATA:
Available. ADDITIONAL DATA: Alcohol may enhance the toxic effects.
===================== Ecological Information =====================
Ecological:Not available
==================== Disposal Considerations ====================
Waste Disposal Methods:Dispose in accordance with all applicable
regulations. Subject to disposal regulations: U.S. EPA 40 CFR 262.
Hazardous Waste Number(s): D001. D003.
=================== MSDS Transport Information ===================
Transport Information:U.S. DOT 49 CFR 172.101: PROPER SHIPPING NAME:
Butadienes, inhibited ID NUMBER: UN1010 HAZARD CLASS OR DIVISION:
2.1 LABELING REQUIREMENTS: Flammable gas QUANTITY LIMITATIONS:
PASSENGER AIRCRAFT OR RAILCAR: Forbidden CARGO AIRCRAFT ONLY: 150
kg
===================== Regulatory Information =====================
SARA Title III Information: SARA TITLE III SECTION 302 EXTREMELY
HAZARDOUS SUBSTANCES (40 CFR 355.30): Not regulated. SARA TITLE
III SECTION 304 EXTREMELY HAZARDOUS SUBSTANCES (40 CFR 355.40): Not
regulated.SARA TITLE III SARA SECTIONS 311/312 HAZARDOUS
CATEGORIES (40 CFR 370.21): ACUTE: Yes CHRONIC: Yes FIRE: Yes
REACTIVE: Yes SUDDEN RELEASE: YesSARA TITLE III SECTION 313 (40
CFR 372.65): 1,3-Butadiene
Federal Regulatory Information:CERCLA SECTIONS 102a/103 HAZARDOUS
SUBSTANCES (40 CFR 302.4):1,3-Butadiene: 10LBSRQ OSHA PROCESS
SAFETY (29CFR1910.119): Not regulated.
State Regulatory Information: California Proposition 65: Known to the
state of California to cause the following: 1,3-Butadiene Cancer
(Apr 01, 1988)
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TM2136 FAST DRY WHITE, TRAFFIC (SUPDAT)
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL (SARA 313) (CERCLA). VP: 92.0.
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 4%
OSHA PEL:200 PPM, S
ACGIH TLV:200 PPM; 250 STEL, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-(2-BUTOXYETHOXY)-ETHANOL. VP: 0.1.
CAS:112-34-5
RTECS #:KJ9100000
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CALCIUM CARBONATE
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 40%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 6%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:VOLATILE ORGANIC COMPOUND, TOTAL: 0.76 LBS/GAL; VOC LESS
WATER: 1.10 LBS/GAL
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HNDLG/STOR PRECS: TO APPRVD CNTNRS W/COMPLETE & APPROP
LABELING. DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
RTECS #:9999999ZZ
Ingred Name:OTHER PRECS: PARTICULATES (LISTED "AS DUST" IN INGRED
SECTION) WHICH MAY BE PRESENT AT HAZ LEVELS ONLY DURING (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: SANDING OR ABRADING OF DRIED FILM. IF NO SPECIFIC
DUSTS ARE LISTED, APPLIC LIMS FOR NUISANCE DUSTS ARE (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: ACGIH TLV 10 MG/M3 (TDUST), OSHA PEL 15 MG/M3
(TDUST), 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ
Ingred Name:RESP PROT: NIOSH FOR PROTECTION AGAINST NON-VOLATILE
MATERIALS IN INGRED SECTION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN & RESP
SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESS. EXTREME OVEREXP MAY RSLT
IN UNCON & POSS DEATH. HDCH, DIZZ, NAUS & LOSS OF COORD ARE
INDICATIONS OF EXCESSIVE EXPOS TO VAPS OR SPRAY MISTS. REDNESS &
ITCH OR BURNING SENSATION MAY INDICATE EYE OR EXCESSIVE SKIN EXPOS.
CHRONIC: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: PRLNGD OVEREXP TO SOLVENT INGREDS
LISTED MAY CAUSE ADVERSE EFTS TO LIVER & URINARY SYSTEMS. RATS
EXPOSED TO TITANIUM DIOXIDE DUST AT 250 MG/M3 DEVELOPED LUNG
CANCER, HOWEVER, SUCH EXPOS LEVE LS ARE NOT ATTAINABLE IN THE
WORKPLACE.REPORTS HAVE ASSOC RPTD & PRLNGD OVEREXP TO SOLVENTS
W/PERM BRAIN & (SUPDAT)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP
AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE.
EYES: FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION. INGEST: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:104F,40C
Lower Limits:0.9%
Upper Limits:36.5%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. APPLICATN TO HOT SURFS (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT & OPEN FLAME.
CONSULT NFPA CODE. USE APPRVD BONDING & GROUNDING PROCS. KEEP CNTNR
CLSD WHEN NOT IN USE. TRANSFER ONLY (ING 6)
Other Precautions:INTENTIONAL MISUSE BY DELIB CONC & INHAL CONTENTS CAN
BE HARMFUL/FATAL. USE ONLY W/ADEQ VENT. AVOID BRTHG VAP & SPRAY
MIST. AVOID CNTCT W/SKIN & EYES. WASH HANDS AFTER USING. THESE
COATINGS MAY CONTAI N MATLS CLASSIFIED AS NUISANCE (ING 7)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMITS BY VENT, WEAR PROPERLY FITTED, NIOSH APPRVD ORG
VAP/PARTICULATE RESP. WHEN SANDING, WIREBRUSHING, ABRADING,
BURNING/WELDING DRIED FILM, WEAR PARTICULATE RESP APPRVD BY (ING
10)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS MAINTAINED
BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS 1910.94, 107, 108.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: MARKING PAINT (WATERBORNE). EXPLO HAZ: REQS
SPEC PRECS. DURING EMER CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE
HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED ATTN. EFTS
OF OVEREXP: NERVOUS SYS DMG. CONTAINS CHEM(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>148F,>64C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.60
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:39-51
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS LISTED IN INGREDIENT SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PRODS MAY BE HAZ AS DEFINED UNDER
RCRA 40CFR261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERM
APPLIC EPA HAZ WASTE NUMBER. INCIN IN APPRVD FACILITY. DO NOT INCIN
CLSD CNTNR. DISP OF I/A/ W FED, STATE & LOCAL REGS REGARDING
POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PAINT, ACRYLIC EMULSION, WHITE #37875
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENT
Fraction by Wt: 37.0%
ACGIH TLV:NO HAZARD
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 43.5%
ACGIH TLV:NO HAZARD
Ingred Name:ACRYLIC RESINS
Fraction by Wt: 19.5%
ACGIH TLV:NO HAZARD
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:NONE KNOWN
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:INGESTION: INDUCE VOMITING. GET MEDICAL ATTENTION. EYES:
FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Extinguishing Media:NON-FLAMMABLE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:MATERIAL MAY SPATTER WHEN TEMPERATURE
EXCEEDS BOILING POINT (212F)
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH AWAY WITH WATER OR ABSORB ON APPROPRIATE
ABSORBANT.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT FREEZE.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED
Ventilation:LOCAL-ONLY TO AVOID EXCESSIVE INHALATION WHEN SPRAYING.
Other Protective Equipment:FULL WORK CLOTHING
Work Hygienic Practices:WASH THOROUGHLY AFTER PAINTING AND BEFORE
EATING OR SMOKING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F, 100C
Decomp Temp:Decomp Text:>212F,>100C
Vapor Pres:16
Vapor Density:0.6
Spec Gravity:1.38
pH:7
Evaporation Rate & Reference:SAME AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:WHITE PAINT
Percent Volatiles by Volume:58.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE LISTED
Stability Condition to Avoid:AVOID FREEZING TEMPERATURES
Hazardous Decomposition Products:NONE LISTED
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:S64Y532 YELLOW OXIDE
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB * 96-3 *
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 2%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:50 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
Ingred Name:ETHYLENE GLYCOL, GLYCOL *96-3*
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 3%
Other REC Limits:10 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:DIMETHYL AMINOETHANOL
CAS:108-01-0
RTECS #:KK6125000
Fraction by Wt: 3%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 61.8%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION TO EYES, SKIN & UPPER
RESPIRATORY SYSTEM. PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE
ADVERSE EFFECTS TO THE LIVER, URINARY & BLOOD-FORMING SYSTEMS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, NAUSEA, DIZZINESS,
REDNESS, ITCHING, BURNING SENSATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/WATER
FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CO2, DRY CHEMICAL, ALCOHOL FOAM
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. USE WATER TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE DUE TO THE
BUILDUP OF PRESSURE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE & REMOVE
W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE & APPROPRIATE
LABELING. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID BREATHING VAPOR
& SPRAY MIST. AVOID CONTACT W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA. WHEN SANDING/ABRADING THE DRIED
FILM, WEAR DUST/MIST RESPIRATOR APPROVED BY NIOSH/MSHA.
Ventilation:LOCAL/GENERAL EXHAUST VENTILATION
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH: 8.5-9.5
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-388F
Vapor Density:>1
Spec Gravity:1.1-1.4
pH:(SUPP)
VOC Grams/Liter:2.51
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:61-97
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:BY FIRE: CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT HAZARDOUS. INCINERATE IN APPROVED FACILITY.
DON'T INCINERATE CLOSED CONTAINERS. DISPOSE OF IAW/FEDERAL, STATE &
LOCAL REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:01475 TAX EXEMPT LOW SULFUR WNTRZ'D 50/50 DIESEL 2
CAGE:2R503
CAGE:2R503
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCARBONS; (COMPLEX MIX OF HYDROCARBS PRDCED BY CRUDE
OIL DISTIL. CONSISTS PREDOMINANTLY OF HYDROCARBS RANGING(ING 2)
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 1:FROM C-9 TO C-20, & BOILING IN RANGE OF 325-675F.
HYDROTREATED/HYDROSULFURIZED PROD ALSO CONTAINS SOME (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:HYDROCARBS PRDCED BY DISTIL OF CATALYTIC CRACKING.
LATTER MATLS CONTAIN BICYCLIC & TRICYCLIC AROMATIC HYDROCARBS.)
RTECS #:9999999ZZ
Ingred Name:CUMENE (SARA 313) (CERCLA). % (WT):0.01-0.09
CAS:98-82-8
RTECS #:GR8575000
Fraction by Wt: SEE ING
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BENZENE (SARA 313) (CERCLA). % (WT):0.01-0.90
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: SEE ING
OSHA PEL:SEE 1910.1028
ACGIH TLV:10 PPM; A2
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:SUPDAT:INFO:MIDDLE DISTIL HAVE CAUSED SKIN IRRIT & SKIN
CANCER IN LAB ANIMALS WHEN RPTDLY APPLIED & LEFT IN PLACE(ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:BETWEEN APPLIC. STUDIES TO FURTHER EVAL CARCIN POTNTL
OF MIDDLE DISTIL ARE CURRENTLY UNDERWAY. KIDNEY DMG (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:HAS ALSO BEEN OBSERVED IN LAB ANIMALS EXPOS TO MIDDLE
DISTIL. CHRONIC:NIOSH HAS REC WHOLE DIESEL EXHAUST (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:BE REGARDED AS POTNTL OCCUP CARCIN, BASED ON FINDINGS
OF CARCIN RESPONSES IN LAB ANIMALS EXPOS TO WHOLE (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:DIESEL EXHAUST. EXCESS CANCER RISK FOR WORKERS EXPOS
TO DIESEL EXHAUST HAS NOT BEEN CALCULATED; (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:PROBABILITY OF DEVELOPING CANCER SHOULD BE DECR BY
MINIMIZING EXPOS TO LOWEST FEASIBLE LIMS. RPTD SKIN (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:CONT MAY CAUSE PERSISTENT IRRITATION OR DERMATITIS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:IS CONSCIOUS & CAN SWALLOW, GIVE 2 GLASSES
OF WATER(16 OZ) BUT DO NOT INDUCE VOMIT. IF VOMIT (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:OCCURS, GIVE FLUIDS AGAIN. HAVE MED PERS DETERM IF
EVAC OF STOM/INDUCTION OF VOMIT IS NEC. DO NOT GIVE (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:ANYTHING BY MOUTH TO UNCON/CONVL PERSON.
INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG, CLEAR PERSON'S AIRWAY (ING
17)
RTECS #:9999999ZZ
Ingred Name:ING 16:GIVE ARTF RESP. IF BRTHG IS DFCLT, QUALIFIED MED
PERS MAY ADMIN OXYG. GET MED ATTN IMMED. OTHER (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:INSTRUCTIONS:REMOVE & DRY-CLEAN/LAUNDER CLTHG
SOAKED/SOILED W/THIS MATL BEFORE REUSE. DRY CLEANING OF (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:CONTAMD CLTHG MAY BE MORE EFTIVE THAN NORM
LAUNDERING. INFORM INDIVIDUALS RESPONSIBLE FOR CLEANING OF (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:POTNTL HAZS ASSOC W/HNDLG CONTAMD CLTHG. ASPIR OF
PROD DURING INDUCED EMESIS MAY RSLT IN SEV LUNG INJURY.(ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:IF EVAC OF STOM IS NEC, USE METH LST LIKELY TO CAUSE
ASPIR, SUCH AS GASTRIC LAVAGE AFTER ENDOTRACHEAL (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21:INTUBATION. CONT POIS CTL CTR FOR ADDITIONAL
TREATMENT INFORMATION.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:>100,000 POUNDS OF PROD IS SPILLED, RPT SPILL
ACCORD TO SARA 304 &/OR CERCLA 102(A) REQUIREMENTS, (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23:UNLESS PROD QUALIFIES FOR PETROLEUM EXEMPTION
(CERCLA SECTION 101(14)).
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 9.00 ML/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:EYES:MAY CAUSE IRRIT,
EXPERIENCED AS MILD DISCOMFORT & SEEN AS SLIGHT EXCESS REDNESS OF
EYE. SKIN:CAUSES SEV IRRIT W/PAIN, SEV EXCESS REDNESS & SWELL
W/CHEM BURNS, BLISTER FORMATION, & POSS TISS DESTRUCTION. PRLNGD,
WIDESPREAD/RPTD SKIN CONT MAY RSLT IN ABSORP OF POTNTLY HARMFUL
AMTS OF MATL. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:BENZENE:IARC MONOGRAPHS, SUPP, VOL 7, PG
120, 1987:GROUP 1. NTP 7TH ANNUAL RPT ON CARCINS, 1994:KNOWN TO BE
(SUPDAT)
Effects of Overexposure:HLTH HAZ:INHAL:VAPS/MIST MAY CAUSE IRRIT OF
NOSE & THROAT. MAY CAUSE DIZZ, DROW, EUPHORIA, LOSS OF
COORDINATION, DISORIENTATION, HDCH, NAUS, & VOMIT. IN POORLY
VENTILATED AREAS/CONFINED SPACES, UNCON & ASPHY MAY RSLT.
PRLNGD/RPTD OVEREXP MAY RSLT IN ABSORP OF POTNTLY HARMFUL AMTS OF
MATL. INGEST:IF MORE THAN (SUPDAT)
Medical Cond Aggravated by Exposure:SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS (SKIN CONDITION).
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/PLENTY OF WATER FOR @ LST 15 MINS. HOLD
EYELIDS APART WHILE FLUSHING TO RINSE ENTIRE SURF OF EYE & LIDS
W/WATER. GET MED ATTN. SKIN:IMMED REMOVE CONTAM CLTHG & SHOES.
UNDER SFTY SHO WER, FLUSH SKIN THOROUGHLY W/LG AMTS OFRUNNING WATER
FOR @ LST 15 MINS. DO NOT ATTEMPT TO NEUT W/CHEM AGENTS. GET MED
ATTN IMMED. DISCARD/DECONTAM CLTHG & SHOES BEFORE REUSE. INGEST:IF
PERSON(ING 14)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:125F,52C
Lower Limits:0.5%
Upper Limits:4.1%
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL, FOAM/CARBON DIOXIDE
TO EXTINGUISH FLAMES. USE WATER SPRAY TO COOL FIRE-EXPOSED CNTNRS.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . APPROACH
FIRE FROM UPWIND TO AVOID HAZ VAPS & TOX DECOMP PRODS.
DECONTAM/DISCARD ANY CLTHG CONTAINING CHEM (SUPDAT)
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. AVOID BRTHG VAP. WEAR APPROP
PERSONAL PROT EQUIP, INCL APPROP NIOSH APPRVD RESP PROT. CONTAIN
SPILL IF POSS. WIPE UP/ABSORB ON SUITABLE MATL & SHOVEL UP. PVNT
ENTRY INTO SEWERS & WATER WAYS. AVOID CONT W/SKIN, EYES/CLTHG.
IF(ING 23)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT & OPEN FLAME.
PERIODS OF EXPOS TO HIGH TEMPS SHOULD BE MINIMIZED. WATER CONTAM
SHOULD BE AVOIDED. KEEP AWAY FROM HEAT & FLAME.
Other Precautions:AVOID BREATHING VAPOR, MIST, OR GAS. KEEP CONTAINER
CLOSED. NEVER SIPHON BY MOUTH. USE ONLY WITH ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . FOR MORE SPECIFIC INFORMATION CONTACT NEHC .
Ventilation:LOC EXHAUST VENT REC IF GENERATING VAP, DUST/MIST. IF
EXHAUST VENT IS NOT AVAIL/INADEQ, USE NIOSH APPRVD RESP AS APPROP.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:LAUNDER/DRY-CLEAN WHEN SOILED. AVOID CONT
W/EYES, SKIN & CLTHG. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRE FIGHT PROC:RESIDUES. EXPLAN OF CARCIN: CARCIN FED REGISTER, VOL
52, PG 34460, 1987:OSHA-CANCER HAZ. HUMAN:MYELOID LEUKEMIA,
HODGKINS DISEASE, LYMPHOMIA. EFTS OF OVEREXP:SEVERAL MOUTHFULS ARE
SWAL LOWED, ABDOM DISCOMFORT, NAUS, & DIARR MAY OCCUR. ASPIR MAY
OCCUR DURING SWALLOWING/VOMIT RSLTG IN LUNG DMG. TOX:(ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:650F,343C
Vapor Pres:<10 @ 68F
Spec Gravity:0.8521(WATER=1)
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:<0.1%
Appearance and Odor:BRIGHT AND CLEAR LIQUID (TAX EXEMPT DIESELS-PALE
RED LIQUID), PETROLEUM ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HEAT, STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PRODS EVOLVED WHEN SUBJECTED TO
HEAT/COMBUST:TOX LEVELS OF CO*2, CO, IRRITATING ALDEHYDES &
KETONES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . FOR MORE SPECIFIC INFORMATION CONTACT NEHC .
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SILVER OXIDE
CAGE:22527
CAGE:22527
============= Composition/Information on Ingredients =============
Ingred Name:SILVER OXIDE
CAS:20667-12-3
RTECS #:VW4900000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.01 MG AG/M3
ACGIH TLV:0.01 MG AG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL RATS: 2820MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT W/SKIN CAUSES IRRIT,POSSIBLE
BURNS ESPECIALLY IF SKIN WET/MOIST.MAY CAUSE CYANOSIS W/BLUISH
SKIN.EYE/SKIN:SEVERE IRRIT,POSSIBLE BURNS.INGEST:HARMFUL.MAY CAUSE
SEVERE GI TRACT IRRIT W/NAU,VOMIT ,POSSIBLE BURNS.INHAL:IRRIT RESP
TRACT W/BURNING PAIN IN NOSE/THROAT,COUGH,WHEEZING,SHORTNESS OF
BREATH,PULM EDEMA.(SUP)
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY:NOT LISTED BY
ACGIH,IARC,NIOSH,NTP,OSHA.
Effects of Overexposure:HARMFUL IF SWALLOWED. SKIN IRRIT, BURNS, SEVERE
RESP TRACT IRRIT, SEVERE SKIN IRRIT, BURNS, CYANOSIS W/BLUISH SKIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
TARGET ORGANS:NONE
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST 15MINS LIFT
UPPER/LOWER LIDS.GET MED AID IMMED.DONT ALLOW VICTIM TO RUB OR KEEP
EYE CLSD.SKIN:GET MED AID IMMED.IMMED FLUSH W/PLENTY OF SOAP/WATER
FOR @LEA ST 15MINS WHILE REMOVING CONTMAIN
CLOTH/SHOES.INGSET:CONSC/ALERT GIVE 2-4CUPFULS OF MILK/WATER.NEVER
GIVE ANYTHING BY MOUTH IF UNCONSC.GET MED AID IMMED.INHAL:GET MED
AID IMMED.REMOVE TO FRESH(SUPPLE)
===================== Fire Fighting Measures =====================
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:N/AVAI
Upper Limits:N/AVAI
Extinguishing Media:SM:USE DRY CHEMICAL,CO2,WATERSPRAY OR
ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:WEAR APPROPRIATE PROTECTIVE CLOTHING TO
PREVENT CONTCT W/SKIN/EYES.WEAR SELF-CONTAINED BREATHING APPARATUS
(SCBA) TO PREVENT CONTACT W/THERM DECMPO PRODUCTS.
Unusual Fire/Explosion Hazard:DANGER!STRONG OXIDIZER.CONTACT W/OTHER
MATL MAY CAUSE FIRE.COTNACT W/COMBUST MATLS MAY CAUSE FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PPE/EQPMT.VAC/SWEEP UP MATL.PLACE
INTO SUITABLE DISPO CNTNR.AVOID GENERATING DUSTY CONDITIONS.REMOVE
ALL IGN SOURCES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE W/ADEQU VENTI.KEEP CNTNR TIGHTLY
CLSD.AVOID CLOTH/COMBUST MATLS CONTACT.DONT GET IN EYE/SKIN.DONT
INGEST/INHAL.DONT STORE NEAR COMBUST MATLS.
Other Precautions:KEEP AWAYF ROM SOURCES OF IGN.DONT STORE NEAR COMBUST
MATLS.STORE IN TIGHTLY CLSD CNTNRS.STORE IN COOL DRY WELL-VENTI
AREA AWAY FROM INCOMPATIBLE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW OSHA RESP REGS FOUND IN
29CFR1910.134.ALWAYS USE NIOSH-APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:USE ADEQUATE GEN/LOC EXHAUS VENTI TO KEEP AIRBORNE CONCEN
BEL PERMISSIBLE EXPO LIMITS.
Other Protective Equipment:EYEWARE IAW 29CFR1910.133.WEAR APPROPRIATE
PROTECTIVE CLOTH TO PREVENT SKIN EXPO.
Work Hygienic Practices:WASH THOROUGHLY AFT HNDLG.
Supplemental Safety and Health
HEALTH:INHAL:CHRONIC:NOT AVAI.CHRONIC INHAL/INGEST CAUSE ARGYRIA
CHARACT-BLUE-GRAY PIGMENTATION OF SKIN/MUC MEMB.LOC ARGYRIA-PERM
DISCOLORATION OF SKIN,PIGMENTATION PERM. 1STAID:AIR IMMED.NOT
BREATH G IVE ART RESP;DIFFI BREATH GIVE OXY.DR:TREAT SYMPT/SUPPORT.
INCOMPA:(IGN),H2S(IGN),HYDRAZINES,AMINES,S,METAL SULFIDES,CO.
================== Physical/Chemical Properties ==================
HCC:D1
Boiling Pt:B.P. Text:N/AVAI
Melt/Freeze Pt:M.P/F.P Text:392F,200C
Decomp Temp:Decomp Text:N/AVAI
Vapor Pres:N/AVAI
Vapor Density:N/AVAI
Spec Gravity:7.14
pH:N/AVAI
Viscosity:N/AVAI
Evaporation Rate & Reference:N/AVAI
Solubility in Water:NEGLIGIBLE IN WATER
Appearance and Odor:BROWNISH, BLACK HEAVY POWDER. SOLID, ODORLESS
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COMBUST MATLS,ORG MATLS,REDUCING AGENTS.AMMONIA(RXS DANGEROUSLY),GRIND
W/METAL SULFIDES,SELENIUM,SULFUR,PHOSPHORUS(SUPP)
Stability Condition to Avoid:ABSORBS CO2 FROM AIR.CONTACT W/MATL CAUSE
FIRE.
Hazardous Decomposition Products:OXYGEN, SILVER FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:NONE SPECIFIED BY MANUFACTURER. HMIS:DISPOSE OF
IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STYLETONE 835 SERIES, 2035001
CAGE:SMILA
CAGE:SMILA
CAGE:0ZZW8
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE (2:3); (ALUMINUM OXIDE) (SARA 313)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 1.0%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL) VP: 0.1 @ 68F
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETIC ACID, VINYL ESTER; (VINYL ACETATE MONOMER) (SARA
302/313) (CERCLA)VP: 92 @ 68F
CAS:108-05-4
RTECS #:AK0875000
Fraction by Wt: 0.13%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM; 15 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER WITH
2,2,4-TRIMETHYL-1,3-PENTANEDIOL; (ESTER ALCOHOL) VP: 1 @ 189F
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND: 1.12 LBS/GAL (134 G/L) COATING
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: ADVERSE HEALTH EFFECTS FROM
VAPORS OR SPRAY MISTS IN POORLY VENTILATED AREAS MAY INCLUDE IRRIT
OF MUC MEMBS OF NOSE, THROAT & RESP TRACT & SYMPS OF HDCH & NAUS.
EYES: IN DIRECT CONTACT, MAY CAU SE IRRIT. SKIN: PRLNGD & RPTD
CONTACT W/PROD MAY CAUSE SKIN IRRIT. SKIN ABSORPTION: REDNESS,
DRYING (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OF SKIN OR OTHER SIGNS OF IRRIT OR
CONTACT DERM. INGEST: CAN CAUSE GI IRRIT, NAUS, VOMIT & DIARR.
CHRONIC: PRLNGD/RPTD EXPOSURES ABOVE TLV MAY RESULT IN PERM BRAIN &
NERVOUS SYSTEM DAMAGE. W ARNING. PRODUCT MAY CONTAIN CHEMS KNOWNTO
THE STATE OF CA TO CAUSE CANCER, BIRTH DEFECTS &/OR OTHER REPRO
HARM.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. TAKE TO MD. SKIN: WASH AFFECTED AREAS WITH SOAP & WATER.
REMOVE CONTAMINATED CLOTHING. IF IRRITATION PERSISTS, CONSULT MD.
INHAL: REMOV E TO FRESH AIR. TREAT SYMPTOMATICALLY. CONSULT MD.
INGEST: DRINK 1 OR 2 GLASSES OF WATER TO DILUTE. DO NOT INDUCE
VOMITING. CONSULT MD OR POISON CONTROL CENTER IMMEDIATELY. TREAT
SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:214F,101C
Lower Limits:0.6%
Upper Limits:12.5%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . COOL CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:CLOSED CONTAINER EXPOSED TO HIGH
TEMPERATURES MAY EXPLODE OR BURST DUE TO BUILD UP OF STEAM
PRESSURE.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE, CONTAIN OR ABSORB WITH INERT MATERIALS.
TRANSFER TO CONTAINER FOR RECOVERY OR DISPOSAL. PREVENT RUNOFF INTO
SEWERS, STREAMS OR OTHER BODIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT EXPOSE TO EXTREMES IN
TEMPERATURE. AVOID EXPOSURE TO HIGH TEMPERATURES. DO NOT ALLOW TO
FREEZE.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PROLONGED OR REPEATED
EXPOSURE TO LEVELS ABOVE TLV. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. IF TLV IS EXCEEDED USE
NIOSH/MSHA APPROVED ORGANIC VAPOR AND MIST, SUPPLIED AIR OR
SELF-CONTAINED BREATHING APPARATUS.
Ventilation:USE ADEQUATE MECHANICAL (GENERAL AND/OR LOCAL) VENTILATION
TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR IMPERVIOUS CLOTHING.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING RESTROOMS.
REMOVE AND WASH ALL CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>369F,>187C
Vapor Pres:SEE INGS
Vapor Density:LTR/AIR
Spec Gravity:1.2 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:COMPLETE
Appearance and Odor:TYPICAL FOR WATER BASED PAINTS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS, CARBON
DIOXIDE, CARBON MONOXIDE, VARIOUS HYDROCARBONS, ETC ON THERMAL
DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ACT-1 SPRAY COATING (BLACK)
Preparer's Name:RUDOLPH OPPENHEIM
CAGE:FO773
CAGE:FO773
CAGE:1Y165
============= Composition/Information on Ingredients =============
Ingred Name:LIGROINE; (VM&P NAPHTHA)
CAS:8032-32-4
RTECS #:OI6180000
OSHA PEL:300 PPM;400 STEL
ACGIH TLV:300 PPM
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (GL 100
SOLVENT)
CAS:64742-95-6
RTECS #:WF3400000
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:ACETONE (SARA III). BP: 133F,56C.
CAS:67-64-1
RTECS #:AL3150000
OSHA PEL:750 PPM;1000PPM STEL
ACGIH TLV:750 PPM;1000PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPELLANT BLEND CONTAINING ING 6 & 7
RTECS #:9999999ZZ
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:BUTANE; (N-BUTANE)
CAS:106-97-8
RTECS #:EJ4200000
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE LISTED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: PROLONGED INHALATION OF
CONCENTRATED VAPORS MAY CAUSE HEADACHES, DIZZINESS, NAUSEA AND
ANESTHESIA. REPEATED CONTACT WITH SKIN AND EYES CAN CAUSE
IRRITATION. CHRONIC: NOT KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT KNOWN.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER. EYES: FLUSH WITH WATER FOR AT
LEAST 15 MINUTES AND CONSULT PHYSICIAN/OPHTHALMOLOGIST IMMEDIATELY.
INGESTION: DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL HELP.
INHALAT ION: REMOVE TO FRESH AIR AND GIVE ARTIFICIAL RESPIRATION IF
NECESSARY. GET MEDICAL HELP IF DISCOMFORT PERSISTS.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WATER SPRAY MAY BE USED TO COOL CANS IN
VICINITY OF FIRE OR EXCESSIVE HEAT.
Unusual Fire/Explosion Hazard:TEMPERATURES ABOVE 120F MAY CAUSE CANS TO
BURST. FLAME PROJECTION: OVER 18 IN WITH FLASHBACK.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP SPILLAGE WITH INERT ABSORBENT
MATERIAL.
Neutralizing Agent:NONE LISTED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:FOR INDUSTRIAL USE ONLY. STORE IN DRY
COOL PLACE BELOW 120F.
Other Precautions:KEEP OUT OF REACH OF CHILDREN AND PETS. AVOID
PROLONGED AND REPEATED CONTACT WITH SKIN AND EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE WHEN USED WITH GOOD VENTILATION AND BELOW
TLV. WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:LOCAL EXHAUST PREFERED. MECHANICAL (GENERAL) OPTIONAL.
Other Protective Equipment:EYEWASH FACILITIES MEETING ANSI DESIGN
CRITERIA.
Work Hygienic Practices:WASH HANDS AFTER USE.
Supplemental Safety and Health
NONE LISTED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:SEE ING 4
Evaporation Rate & Reference:FASTER THAN BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:PAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, OPEN FLAME.
Stability Condition to Avoid:TEMPERATURES ABOVE 120F.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD TOXIC
GASES; I.E. CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF CAN IN NON-INCINERATED TRASH ONLY.
HANDLE AS EXTREMELY FLAMMABLE MATERIAL. KEEP AWAY FROM OPEN FLAME
AND TEMPERATURES ABOVE 120F. DISPOSE OF IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGU LATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GROUP A: 60AP
CAGE:28835
CAGE:28835
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 70-90%
Other REC Limits:5 MG/M3 AS FE
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1-6%
Other REC Limits:NONE SPECIFIED
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 2-10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:POTASSIUM SILICATE
CAS:1312-76-1
Fraction by Wt: <5%
Other REC Limits:0.1 MG/M3 AS SILICA
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
Fraction by Wt: 3-15%
Other REC Limits:0.1 MG/M3 AS SILICA
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION OF WELDING FUMES MAY
CAUSE METAL FUME FEVER. ELECTRIC SHOCK, THERMAL BURNS, ULTRAVIOLET
RADIATION BURNS ARE ALSO HAZARDS. CHRONIC:SIDEROSIS, SILICOSIS AND
FIBROSIS OF THE LUNGS, ANDMANGANISM EFFECTS OF THE CENTRAL
NERVOUS SYSTEM ARE POSSIBLE CHRONIC EFFECTS OF CHRONIC OVEREXPOSURE
TO WELDING FUMES.
Explanation of Carcinogenicity:THE PRODUCT CONTAINS NO INGREDIENT AT
0.1% OR GREATER THAT IS LISTED BY IARC, NTP OR OSHA AS A
CARCINOGEN.
Effects of Overexposure:EXPOSURE TO WELDING FUMES MAY RESULT IN
DISCOMFORT SUCH AS DIZZINESS, NAUSEA, FEVER, DRYNESS AND/OR
IRRITATION OF NOSE, THROAT AND EYES. SKIN SENSITIVITY MAY ALSO BE
NOTED. WATERY EYES, HEADACHE, BREA THING DIFFICULTY, FREQUENT
COUGHING AND/OR CHEST PAINS MAY OCCUR FROM ACUTE EXPOSURE. TOXIC
GASES CAN BE FATAL.
Medical Cond Aggravated by Exposure:IMPAIRED PULMONARY FUNCTION (ASTHMA
LIKE ILLNESS) MAY HAVE SYMPTOMS EXACERBATED BY IRRITANTS CONTAINED
IN WELDING FUMES.
======================= First Aid Measures =======================
First Aid:ADMINISTER FIRST AID AS RECOMMENDED BY THE AMERICAN RED
CROSS. INHALED:REMOVE FROM EXPOSURE. SUPPORT OR RESTORE BREATHING
AND GET MEDICAL ATTENTION AS NEEDED. ELECTRICAL SHOCK:TURN OFF
POWER, ADMINI STER FIRST AID AND GET IMMEDIATE MEDICAL ATTENTION.
THERMAL AND RADIATION BURNS;SKIN:NORMAL FIRST AID. SEE DOCTOR IF
NEEDED. RADIATION BURNS;EYES:GET IMMEDIATE MEDICAL CARE.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:PRODUCT IS NON FLAMMABLE. EXTINGUISH FIRE WITH
MEDIA APPROPRIATE FOR SOURCE OF FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING FIRE.
Unusual Fire/Explosion Hazard:ARCS, SPARKS OR HOT METAL FROM A WELDING
OPERATION MAY IGNITE NEARBY COMBUSTABLE MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:MFR:NOT APPLICABLE. HMIS:CLEAN UP ANY
GRINDING DUST OR WASTE RESIDUES AND PLACE IN SUITABLE DOT APPROVED
CONTAINERS FOR RECLAIM OR DISPOSAL.
Neutralizing Agent:NO INFORMATION GIVEN ON MSDS BY MFR.
======================Handling and Storage ======================
Handling and Storage Precautions:NO INFORMATION GIVEN ON MSDS BY MFR.
HMIS:PRODUCT IS IN HERMETICALLY SEALED CONTAINER; AFTER OPENING
STORE AS DIRECTED ON THE LABEL.
Other Precautions:FOLLOW MANUFACTURERS INSTRUCTIONS. REFER TO ANSI
Z49.1 AND OSHA 29CFR1900 FOR SAFETY IN WELDING INFORMATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED WELD FUME RESPIRATOR OR AIR
SUPPLIED RESPIRATOR WHEN WELDING IN A CONFINED SPACE OR WHERE LOCAL
EXHAUST DOES NOT KEEP EXPOSURE BELOW RECOMMENDED LIMITS.
Ventilation:USE VENTILATION OR LOCAL EXHAUST AT THE ARC TO KEEP THE
FUMES & GASES AT THE WORKERS BREATHING ZONE BELOW THE PEL/TLV.
Other Protective Equipment:FLAME RETARDANT CLOTHING. DO NOT EXPOSE SKIN
TO RADIATION WHEN HOT CUTTING OR WELDING
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE PRACTICE. WASH
AFTER USING THE PRODUCT AND BEFORE EATING, DRINKING, ETC.
Supplemental Safety and Health
KEY2:KT
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID METAL ROD,5/32 IN DIA. X 14 IN LONG, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & ALKALIES.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:WELDING/CUTTING OPERATIONS MAY INCLUDE
ELEMENTAL METALS, OXIDES OF THE METALS, FUMES/GASES &
ELECTROMAGNETIC RADIATION.
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ALL WELDING WAST IN AN
ENVIRONMENTALLY ACCEPTABLE MANNER I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
======================================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HYDRAULIC OIL MA
CAGE:GO225
CAGE:GO225
CAGE:6Y142
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM BASE OIL
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: MILD IRRITATION. INGESTION:
PRACTICALLY NON-TOXIC. PRESURIZED INJECTION OF PRODUCT UNDER THE
SKIN CAN LEAD TO SEROUSLY INFLAMMED TISSUE. IF LEFT, INJURY CAN BE
GANGRENOUS.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINUTES. SKIN: WASH W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: GIVE 2 GLASSES
OF WATER & INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>280F
Extinguishing Media:DRY CHEMICAL, FOAM, CO2.
Fire Fighting Procedures:EVACUATE AREA. SHUT OFF SOURCE. USE NIOSH/MSHA
SCBA & PROTECTIVE EQUIP/CLOTHING. USE WATER FOG/SPRAY TO COOL
EXPOSED CONTAINERS & EQUIPMENT.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. SHUT OF SOURCE.
PROTECT FROM IGNITION. KEEP OUT OF WATER SOURCES. ABSORB IN DRY,
INERT MATERIAL. TRANSFER TO DISPOSAL DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID INHALATION OF MIST & EYE
CONTACT. AVOID REPEATED CONTACT W/SKIN. WEAR PROTECTIVE EQUIPMENT.
STORE AWAY FROM IGNITION SOURCES.
Other Precautions:PROVIDE MEANS OF CONTROLLING LEAKS & SPILLS. KEEP
CONTAINERS CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR
FOR CONCENTRATION EXCEEDING EXPOSURE LIMITS
Ventilation:ADEQUATE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:<1
Vapor Density:>5
Spec Gravity:0.86-0.94
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS TO DARK LIQUID W/MILD ODOR
Percent Volatiles by Volume:NEGL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXYGEN & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:IGNITION SOURCES
Hazardous Decomposition Products:CARBON OXIDES, VARIOUS HYDROCARBONS
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR OTHERWISE MANAGE AT A PERMITTED
WASTE MANAGEMENT FACILITY IN ACCORDANCE W/LOCAL, STATE, & FEDERAL
REGULATIONS. KEEP OUT OF WATER SOURCES & SEWERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CE-PROCESS BLACK TYPE H,4405-32
CAGE:0UWR2
CAGE:50804
CAGE:0UWR2
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS/ISOPARAFFINIC HYDROCARBON SOLVENT
CAS:64475-85-0
RTECS #:PY8240000
Fraction by Wt: >98%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:POLYMERS
Other REC Limits:NONE RECOMMENDED
Ingred Name:PIGMENT
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) >10,000 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- NOT EXPECTED TO BE AN EYE IRRITANT. NOT A SKIN
SENSITIZER, NOR A SKIN IRRITANT. LOW ORAL TOXICITY, BUT ASPIRATION
HAZARD. MAY CAUSE CNS DEPRESS ION. MIST MAY CAUSE RESPIRATORY
IRRITATION. INTENTIONAL INHALATION MAY CAUSE CNS TOXICITY. CHRONIC-
UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT IN DUCE VOMITING. IF CONSCIOUS, DRINK SEVERAL GLASSES OF WATER.
SEEK IMMEDIATE MEDICAL ATTENTION. IF SPONTANEOUS VOMITING OCCURS,
KEEP HEAD BELOW HIPS.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:102F,39C
Lower Limits:0.8%
Upper Limits:7.0%
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED AIR-SUPPLIED
BREATHING EQUIPMENT. COOL CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. PICK UP SPILL WITH NON-FLAMMABLE
ABSORBENT SUCH AS SAND OR VERMICULITE. PREVENT LIQUID FROM ENTERING
SEWERS OR WATERWAYS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA, AWAY
FROM HEAT, FLAMES, SPARKS, HOT SURFACES & INCOMPATIBLE MATERIALS.
KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:DO NOT, CUT, DRILL, GRING, WELD OR DO SIMILAR
OPERATIONS TO "EMPTY" CONTAINERS. THEY CONTAIN FLAMMABLE RESIDUE.
USE PROPER BONDING AND GROUNDING PROCEDURES DURING TRANSFER
OPERATIONS. KEEP OUT OF REAC H OF CHILDREN. DO NOT BREAHTE
VAPOR/MIST
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED WITH XEROX
ENGINEERING SYSTEMS PRODUCTS.
Ventilation:USE EXPLOSION-PROOF VENTILATION EQUIPMENT TO CONTROL VAPOR
CONCENTRATIONS.
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:320F - 356F
Vapor Pres:1 @ 68F
Vapor Density:5.0
Spec Gravity:0.77
VOC Pounds/Gallon:730
Evaporation Rate & Reference:0.3 (N-BUTYL ACETATE=1)
Solubility in Water:IMMISCIBLE
Appearance and Odor:BLACK LIQUID - SLIGHT ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS LIQUID CHLORINE, CONCENTRATED OXYGEN,
SODIUM HYPOCHLORITE OR CALCIUM HYPOCHLORITE
Stability Condition to Avoid:HEAT, FLAMES, SPARKS, HOT SURFACES
Hazardous Decomposition Products:FUMES, SMOKE, CARBON MONOXIDE, CARBON
DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN AN APPROVED INCINERATOR OR
CONTRACT WITH LICENSED CHEMICAL WASTE DISPOSAL SERVICE. DISCHARGE,
TREATMENT OR DISPOSAL IS SUBJECT TO FEDERAL, STATE OR LOCAL LAWS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:30796-16OZ OATEY PURPLE PRIMER/CLEANER
Preparer's Name:GABRIELLA BITZ
CAGE:EO573
CAGE:53472
CAGE:EO573
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 75-80%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TETRAHYDROFURAN (SARA III)
CAS:109-99-9
RTECS #:LU5950000
Fraction by Wt: 1-3%
Other REC Limits:200 PPM
OSHA PEL:200 PPM/250 STEL
ACGIH TLV:200 PPM/250STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 12-24%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VIOLET DYE, C.I. SOLVENT VIOLET 13
CAS:81-48-1
RTECS #:CB7700000
Fraction by Wt: <1%
Ingred Name:CYCLOHEXANONE (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 3-10%
Other REC Limits:100PPM (SKIN) STEL
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:C.I. SOLVENT RED 26
CAS:4477-79-6
Fraction by Wt: <1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: ABSORPTION,
IRRITATION & DERMATITIS. INHALATION: MUCOUS MEMBRANES/NOSE/THROAT
IRRITATION, HEADACHE, DIZZINESS, NAUSEA, NUMBNESS OF THE
EXTREMITIES, NARCOSIS, CENTRAL NERVOUS SY STEM & LIVER DAMAGE.
INGESTION: SYSTEMICA EFFECTS AS W/INHALATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION. SKIN: ABSORPTION, IRRITATION
& DERMATITIS. INHALATION: MUCOUS MEMBRANES/NOSE/THROAT IRRITATION,
HEADACHE, DIZZINESS, NAUSEA, NUMBNESS OF THE EXTREMITIES, NARCOSIS,
CENTRAL NERVOUS SY STEM DEPRESSION & LIVER DAMAGE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR OR
OXYGEN IF NEEDED. KEEP VICTIM QUIET & WARM. INGESTION: DRINK WATER.
AVOID AL COHOLIC BEVERAGES. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:0-5F
Lower Limits:2%
Upper Limits:13%
Extinguishing Media:DRY CHEMICAL, CO2, WATER OR FOAM EXTINGUISHER
Fire Fighting Procedures:EVACUATE AREA & CALL FIRE DEPARTMENT.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. STOP LEAK W/OUT RISK. TAKE-UP
W/SAND, EARTH OR OTHER NON-COMBUSTIBLE ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:ELIMINATE IGNITION SOURCES. STORE IN
COOL, DRY PLACE. CONTAINERS, EVEN EMPTY WILL RETAIN RESIDUE &
VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED CANNISTER RESPIRATOR.
Ventilation:GENERAL, MECHANICAL & LOCAL EXHAUST
Other Protective Equipment:EYE WASH & SAFETY SHOWER
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:133F
Vapor Pres:70
Vapor Density:2
Evaporation Rate & Reference:(BU AC = 1): 6-8
Solubility in Water:COMPLETE
Appearance and Odor:PURPLE LIQUID W/SHARP, PENETRATING ODOR
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZING MATERIALS, ALKALIS, CHLORINATED INORGANICS (POTASSIUM,
CALCIUM & SODIUM HYPOCHLORITE), COPPER/ALLOYS
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME
Hazardous Decomposition Products:CO, CO2, HYDROGEN CHLORIDE & SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. FLAMMABLE LIQUID. UN 1993. IGNITABLE/TOXIC
WASTE, ID 4-213 & F-005.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STYLE 1625 G
Preparer's Name:JANVIER GASANA
CAGE:99189
CAGE:99189
============= Composition/Information on Ingredients =============
Ingred Name:GRAPHITE, NATURAL/GRAPHITE YARNS
CAS:7782-42-5
RTECS #:MD9659600
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MPPCF RDUST
ACGIH TLV:2 MG/M3 RDUST; 9293
Ingred Name:POLYTETRAFLUOROETHYLENE (TEFLON)
CAS:9002-84-0
Other REC Limits:NONE SPECIFIED
Ingred Name:OCTYLPHENOXYPOLYETHOXYETHANOL (NON-IONIC SURFACTANT)
CAS:9036-19-5
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:NO ADVERSE EFFECTS HAVE BEEN REPORTED FROM
HANDLING THIS PRODUCT AT NORMAL CONDITIONS/CIRCUMSTANCES. AT
380C(720F), TEFLON STARTS TO DEGRADE THERMALLY, RELEASING FREON
THAT CAN CAUSE CNS DEPRESSION, L UNG TISSUE DAMAGE, CARDIAC
DYSRHYTHMIA AT HIGH CONCENTRATION. POLYMER FUME FEVER CAUSES COUGH,
FEVER & FLU-LIKE SYMPTOMS
Medical Cond Aggravated by Exposure:NONE EXISTS UNDER NORMAL
CIRCUMSTANCES WHEN HANDLING THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST.EYE/SKIN:FLUSH WITH
WATER FOR 15 MINUTES.HOLD EYELIDS OPEN.INHALED:REMOVE TO FRESH AIR
& PROVIDE OXYGEN/CPR IF NEEDED.ORAL:NONE.SEEK MEDICAL ATTENTION,IF
NEED ED.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CO2, FOAM/DRY CHEMICAL. WATER SPRAY
MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:NOT EXPLOSIVE. MATERIAL WILL NOT SUPPORT
COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT EXPOSE TEFLON CONTAINING MATERIAL TO
TEMPERATURES ABOVE 380 C (720F).
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-STORE THIS PRODUCT AWAY FROM
HEATING SOURCES.
Other Precautions:DO NOT GET IN EYES OR SKIN. WASH THOROUGHLY AFTER
HANDLING. IN PROCESSING AREAS, USE POSTERS AND WARNING LABELS ABOUT
HIGH TOXICITY OF THERMAL DECOMPOSITION VAPORS FROM TEFLON.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED SELF-CONTAINED
BREATHING APPARATUS FOR PROTECTION AGAINST TOXIC THERMAL
DECOMPOSITION VAPORS OF TEFLON.
Ventilation:PROVIDE SUFFICIENT LOCAL EXHAUST VENTILATION WHEN TOXIC
VAPORS ARE GENERATED IN PROCESSING AREAS DUE TO DECOMPOSITION.
Other Protective Equipment:EYE WASH STATION, EMERGENCY SHOWER,
APPROPRIATE LABORATORY COAT TO COVER EXPOSED SKIN
Work Hygienic Practices:DO NOT PERMIT EATING, DRINKING OR SMOKING NEAR
THIS MATERIAL.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:615F,324C
Spec Gravity:2.13 TEFLON
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK SOLID BRAIDED PACKING
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, MOLTEN METAL ALKALIES (ALUMINUM, MAGNESIUM),
ELEMENTAL FLUORINE AND INTERHALOGENATED COMPOUNDS
Stability Condition to Avoid:FLAMES, TEMPERATURES ABOVE 720F (380C)
Hazardous Decomposition Products:FREON, HYDROGEN FLUORIDE,
PERFLUOROCARBON OLEFINS, CARBON MONOXIDE AND CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:DUAL SHIELD WIRES T95-B3
CAGE:GO230
CAGE:GO230
CAGE:84021
============= Composition/Information on Ingredients =============
Ingred Name:MOLYBDENUM (SOLUBLE COMPOUND), LEAD MOLYBDATE
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:10 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:MANGANESE, MN COMPOUNDS
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/CUM (CEILING)
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CALCIUM FLUORIDE, FLUORSPAR, CALCIUM DIFLUORIDE, IRTRAN 3,
LIPARITE
CAS:7789-75-5
RTECS #:EW1760000
Other REC Limits:2.5 MG/CUM (AS F)
OSHA PEL:2.5 MG/CUM (AS F)
ACGIH TLV:2.5 MG/CUM (AS F)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF NOSE, THROAT, EYES. MAY
LEAD TO SIDEROSIS WHICH MAY AFFECT PULMONARY FUNCTION. ARC RAYS CAN
INJURE EYES & BURN SKIN. ELECTRIC SHOCK CAN KILL. SEE SUPP.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:INHALATION: DIZZINESS, NAUSEA, IRRITATION OF
NOSE & THROAT. EYES: IRRITATION. SKIN: DRYNESS & BURNS.
Medical Cond Aggravated by Exposure:RESPIRATORY OR ALLERGIC CONDITIONS.
======================= First Aid Measures =======================
First Aid:EMPLOY FIRST AID TECHNIQUES RECOMMENDED BY THE AMERICAN RED
CROSS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS CAN IGNITE
COMBUSTIBLES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP HEAD OUT OF FUMES, DON'T TOUCH
LIVE ELECTRICAL PARTS, INSULATE FROM WORK & GROUND.
Other Precautions:TO DETERMINE COMPOSITION & QUANTITY OF FUMES & GASES
TO WHICH WORKERS ARE EXPOSED IS TO TAKE AN AIR SAMPLE INSIDE THE
WELDERS HELMET OR IN THE WORKER'S BREATHING ZONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATORY WHEN WELDING IN CONFINED SPACE OR WHERE LOCAL EXHAUST
OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:LOCAL EXHAUST AT THE ARC TO KEEP THE FUMES & GASES BELOW
THE TLV.
Other Protective Equipment:HELMET, ARM PROTECTORS, APRONS, HATS,
Supplemental Safety and Health
THE PRODUCT AS SUPPLIED IS NON-HAZARDOUS. HEALTH HAZARDS OCCUR DURING
OPERATIONS. THE COMPOSTION & QUANTITY OF WELDING FUMES ARE
DEPENDENT ON THE PROCESS, PROCEDURES, MEDIA, CONTAMINENTS IN THE
ATMOSP HERE, & ELECTRODES USED.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SEE SUPP
Stability Condition to Avoid:SEE SUPP
Hazardous Decomposition Products:CO, CO2, OZONE & NITROGEN OXIDES
FORMED BY THE RADIATION FROM ARC. WELDING FUMES - COMPLEX OXIDES
FROM THE INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
W/FEDERAL, STATE & LOC AL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DRI-LUBE PLUS AEROSOL, 5438
Preparer's Name:B MALKEY
CAGE:20913
CAGE:0A6H9
CAGE:20913
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL; (ISOPROPANOL) (SARA 313) LD50 (ORAL
RAT): 5800 MG/KG
CAS:67-63-0
RTECS #:NT8050000
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500 STEL
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE)
CAS:75-28-5
RTECS #:TZ4300000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BUTANE; (N-BUTANE)
CAS:106-97-8
RTECS #:EJ4200000
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: IRRIT W/ITCH, REDNESS &
BLURRED VISION & BURNING SENSATION. SKIN: MAY CAUSE IRRIT W/ITCH,
REDNESS. PRLNG CONT CAN CAUSE DERM. PROD MAY BE ABSORBED THRU SKIN
BUT HARMFUL EFTS ARE NOT EXPEC TED. INHAL: MAY CAUSE HDCH, DIZZ &
NAUS. EXCESS INHAL OF VAPS MAY CAUSE IRRIT TO EYES, NOSE & THROAT
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: W/POSS IMPAIRED COORD, CONFUSION &
CNS DEPRESS. INGEST: MAY CAUSE GI IRRIT W/NAUS, VOMIT & DIARR. LGE
AMTS MAY CAUSE IMPAIRED COORD & CNS DEPRESS W/FATG, HDCH/UNCON, LOW
BLOOD PRESS & REVERS IBLE LIVER EFTS & KIDNEY DMG. CHRONIC: NO DATA
AVAIL. TARGET ORGANS: LIVER, KIDNEY, CNS, HEART, SPLEEN & LUNGS.
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY AND SKIN
CONDITIONS SUCH ASTHMA, EMPHYSEMA, AND DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SEEK MED ATTN IF RESP IRRIT
DEVELOPS/IF BRTHG BECOMES DFCLT. EYES: RINSE W/WATER. REMOVE ANY
CONT LENSES & CONTINUE FLUSHING W/PLENTY OF WATER FOR AT LEAST 15
MIN. SEEK MED ATTN IF IRRIT DEVELOPS. SKIN: WASH W/PLENTY OF SOAP
& WATER FOR SEVERAL MIN. SEEK MED ATTN IF IRRIT DEVELOPS. INGEST:
GIVE 3-4 GLASSES OF WATER, BUT DO NOT INDUCE VOMIT. IF VOMIT
OCCURS, (SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:47.0F,8.3C
Lower Limits:2.0%
Upper Limits:12.7%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL TO DISTANT SOURCES OF IGNITION AND FLASHBACK. USE WATER TO
COOL FIRE-EXPOSED CONTAINERS TO PREVENT BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:DUE TO THE NATURE OF THE AEROSOL PACKAGING, A
LARGE SPILL IS UNLIKELY. FOR A SMALL SPILL, ABSORB WITH AN INERT
MATERIAL AND TRANSFER ALL MATERIAL INTO A PROPERLY LABELED
CONTAINER FOR DISPOSAL. WEAR A PPROPRIATE PROTECTIVE CLOTHING.
Neutralizing Agent:NONE KNOWN.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE INDOOR AT TEMPERATURES BETWEEN
0F AND 120F. AVOID HEAT, HOT SURFACES, SPARKS OR OPEN FLAME.
ADEQUATE VENTILATION
Other Precautions:KEEP OUT OF REACH OF CHILDREN. READ THE ENTIRE LABEL
BEFORE USING THE PRODUCT. FOLLOW THE LABEL DIRECTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITIONS OF USE. A
NIOSH APPROVED RESPIRATOR IN POORLY VENTILATED AREAS OR WHERE
MISTING EXISTS.
Ventilation:GENERAL VENTILATION IS NORMALLY ADEQUATE.
Other Protective Equipment:NONE UNDER NORMAL CONDITIONS OF USE.
EMERGENCY EYEWASH AND DELUGE SHOWER MEETING ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRST AID PROC: GIVE FLUIDS AGAIN. SEEK MED ATTN IF DISCOMFORT OCCURS.
NOTES TO MD: THERE IS NO SPECIFIC ANTIDOTE. TREAT PATIENT
SYMPTOMATICALLY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:180F,82C
Vapor Pres:33
Vapor Density:2.07
Spec Gravity:0.817 (H*2O=1)
Evaporation Rate & Reference:2.88 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY OPAQUE NON-VISCOUS, WITH ALCOHOL ODOR
Percent Volatiles by Volume:94
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS SUCH AS CHLORINE BLEACH AND HYDROGEN PEROXIDE, AND
ACIDS, ACETALDEHYDE AND ISOCYANATE.
Stability Condition to Avoid:AVOID HEAT, HOT SURFACES, SPARKS AND OPEN
FLAMES.
Hazardous Decomposition Products:OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
STATE, AND LOCAL REGULATIONS. TYPICAL DISPOSAL IS TO WRAP THE EMPTY
AEROSOL CONTAINER IN SEVERAL LAYERS OF NEWSPAPER AND DISPOSE OF IN
THE TRASH.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CAUSTIC POTASH-LIQUID, LIQUID 40%
CAGE:0AH54
CAGE:0AH54
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 49-90%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POTASSIUM HYDROXIDE (CERCLA). LD50:(ORAL,RAT) 365 MG/KG.
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 10-51%
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUPDAT:CONT W/ALUMINUM, TIN, ZINC & ALLOYS CNTNG THESE
METALS. DO NOT MIX W/STRONG ACIDS, ALDEHYDES & OTHER ORG (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:CHEMS W/OUT DILUTION & AGITATION TO PVNT
VIOLENT/EXPLO RXN. AVOID CONT W/LEATHER, ORG HALOGEN CMPDS, ORG
(ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:NITRO COMPOUNDS, ACID OR WOOL.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:DESTRUCT TO TISS ON CONT. WILL CAUSE SEV
BURNS THAT RSLT IN DMG INCL BLINDNESS. INGEST:CAN CAUSE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:SEV BURNS & COMPLETE TISS PERFORATION OF MUC MEMBS OF
MOUTH, THROAT, ESOPHAGUS & STOM. CHRONIC:NO KNOWN EFTS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:CANNOT BE DECONTAM. GET MED ATTN IMMED.
INHAL:REMOVE TO FRESH AIR; IF BRTHG IS DFCLT, HAVE TRAINED(ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:PERS ADMIN OXYG. IF RESP STOPS, GIVE MOUTH-TO-MOUTH
RESUSCITATION. GET MED ATTN. INGEST:NEVER GIVE (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:ANYTHING BY MOUTH TO UNCON PERS. IF SWALLOWED, DO NOT
INDUCE VOMIT. GIVE LG QTYS OF WATER. IF AVAIL, GIVE (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:SEVERAL GLASSES OF MILK. IF VOMITING OCCURS
SPONTANEOUSLY, KEEP AIRWAY CLEAR. GET MEDICAL ATTENTION
IMMEDIATELY.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:ALL CLEAN-UP MATL SHOULD BE REMOVED & PLACED IN
APPRVD CNTNRS, LABELED & STORED IN SAFE PLACE TO (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:AWAIT PROPER TREATMENT/DISP. SPILLS ON AREAS OTHER
THAN PAVEMENT, E.G., DIRT/SAND, MAY BE HNDLD BY (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:REMOVING AFFECTED SOILS & PLACING IN APPRVD CNTNRS.
PERS PERFORMING CLEAN-UP WORK SHOULD WEAR ADEQ PPE & (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:CLTHG. SPILLS/RELS SHOULD BE REPORTED, IF REQD, TO
APPROP LOC, STATE & FED REGULATORY AGENCIES. CAUTION: (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:CAUSTIC POTASH MAY REACT VIOLENTLY W/ACIDS & WATER.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:MATLS MAY BE SUBJECT TO MANIFESTING
REQUIREMENTS PER APPLIC REGS. APPROP DISP WILL DEPEND ON (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:NATURE OF EACH WASTE MATL & SHOULD BE PERFORMED BY
COMPETENT & PROPERLY PERMITTED CONTRACTORS. ENSURE (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:THAT ALL RESPONSIBLE FED, STATE & LOC AGENCIES
RECEIVE PROPER NOTIFICATION OF SPILL & DISPOSAL METHODS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:ALWAYS ADD PROD-W/CONSTANT STIRRING-SLOWLY TO
SURF OF LUKEWARM (80-100F) WATER, TO ASSURE PROD IS (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:BEING COMPLETELY DISSOLVED AS IT IS ADDED. IF PROD
ADDED TOO RAPIDLY OR W/OUT STIRRING & BECOMES CONC AT (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21:BOTTOM OF VESSEL, EXCESS HEAT MAY BE GENERATED,
RSLTG IN DANGEROUS BOILING & SPATTERING & POSS IMMED & (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:VIOLENT ERUPTION OF HIGHLY CAUSTIC SOLN. ALWAYS
EMPTY & CLEAN CNTNRS OF ALL RESIDUES BEFORE ADDING PROD, (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23:TO AVOID POSS EXPLO RXN. RETURNABLE CNTNRS SHOULD BE
SHIPPED I/A/W SUPPLIER'S RECS. RETURN SHIPMENTS (ING 25)
RTECS #:9999999ZZ
Ingred Name:ING 24:SHOULD COMPLY W/ALL FED, STATE & DOT REGS. ALL
RESIDUAL CAUSTIC POTASH SHOULD BE REMOVED FROM CNTNRS BEFORE DISP.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 2.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:CORR TO ALL BODY TISS W/WHICH IT
COMES IN CONT. EFT OF LOC EXPOS MAY CONSIST OF MULTIPLE AREAS OF
SUPERFICIAL DESTRUCT OF SKIN/OF PRIMARY IRRIT DERM. SIMILARLY,
INHAL OF DUST, SPRAY/MIST MAY RSL T IN VARYING DEGREES OF IRRIT/DMG
OF RESP TRACT TISS & INCR SUSCEPTIBILITY TO RESP ILLNESS (EFTS
OCCUR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:ONLY WHEN TLV IS EXCEEDED).
INHAL:AIRBORNE CONCS OF MIST/SPRAY MAY CAUSE DMG TO UPPER-RESP
TRACT & EVEN TO LUNG TISS PROPER WHICH COULD PRDCE CHEM PNEUM,
DEPENDING UPON SEVERITY OF EXPOS. SKI N:DESTRUCT TO TISS CONTACTED
& PRDCES SEV BURNS. LATENT PERIOD MAY EXIST BTWN EXPOS & SENSE OF
IRRIT. EYE: (ING 6)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:OBJECT IS TO FLUSH MATL OUT IMMED THEN GET MED ATTN.
IMMED FLUSH W/LG AMTS OF WATER FOR AT LST 15 MINS, HOLDING LIDS
APART TO ENSURE FLUSHING OF ENTIRE SURF. WASHING W/IN SEVERAL SECS
IS ESSNTL T O ACHIEVE MAX EFTIVENESS. GET MED ATTN IMMED.
SKIN:IMMED WASH CONTAM AREAS W/PLENTY OF WATER FOR 15 MINS. REMOVE
CONTAM CLTHG & FOOTWEAR & WASH CLTHG BEFORE REUSE. DISCARD FOOTWEAR
WHICH (ING 8)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:THIS PROD IS NOT COMBUST. WATER SPRAY, FOAM, CARBON
DIOXIDE/DRY CHEMS MAY BE USED IN AREAS WHERE THIS PROD IS STORED.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID DIRECT CONTACT OF THIS PRODUCT W/WATER SINCE THIS
CAN CAUSE A VIOLENT EXOTHERMIC REACTION.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:LEAKS SHOULD BE STOPPED. SPILLS SHOULD BE
CNTND & CLEANED UP IMMED. SPILLS SHOULD BE REMOVED BY USING VACUUM
TRUCK. NEUT REMAINING TRACES OF SPILL. SPILL AREA SHOULD THEN BE
FLUSHED W/WATER FOLLOWED B Y LIBERAL COVERING OF SODIUM
BICARBONATE. (ING 12)
Neutralizing Agent:NEUT W/ANY DILUTE INORG ACID SUCH AS HYDROCHLORIC,
SULFURIC, NITRIC, (SUPP DATA)
======================Handling and Storage ======================
Handling and Storage Precautions:FOR INDUS USE ONLY. DO NOT GET INTO
EYES, ON SKIN, ON CLTHG. AVOID BRTHG DUST, MIST/SPRAY. DO NOT TAKE
INTERNALLY. USE W/ADEQ VENT. KEEP CNTNR CLSD.
Other Precautions:FOLLOW APPROP TANK ENTRY PROCS (ANSI Z117.1).
CONSIDERABLE HEAT IS GENERATED WHEN PROD IS MIXED W/WATER.
THEREFORE, WHEN MAKING SOLNS ALWAYS CAREFULLY FOLLOW THESE
STEPS:ALWAYS WEAR ALL PROT CLTHG DES CRIBED. NEVER ADD WATER TO
PROD.(ING 20)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION IS NOT REQUIRED UNDER
NORMAL USE. USE NIOSH APPROVED RESPIRATORS FOLLOWING MFR'S
RECOMMENDATIONS WHERE DUST, MIST OR SPRAY MAY BE GENERATED.
Ventilation:SPECIAL VENT IS NOT REQD UNDER NORMAL USE. USE LOC EXHST
VENT WHERE MIST/SPRAY MAY BE GENERATED. WHERE CARBON (SUPDAT)
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . IMPERVIOUS PROT CLTHG & CHEM RESIST SFTY SHOES TO MINIMIZE
CONT.
Work Hygienic Practices:WASH THORO AFTER HNDLG/CONT FOR BURNS NOT IMMED
PAINFUL/VISIBLE. WASH CONTAM CLTHG W/SOAP & WATER & DRY BEFORE
REUSE.
Supplemental Safety and Health
PH:0.01 MOLES/LITER HAS PH OF 12. NEUT AGENT:PHOSPHORIC & ACETIC ACID.
VENT:MONOXIDE MAY BE GENERATED, SPECIAL VENT MAY BE REQD. PROT
ING W/MILD SOAP & WATER. EYE PROT:FULL LGTH FSHLD . MATLS TO AVOID:
EXOTHERMIC RXN. WHEN HNDLG PROD, AVOID (ING 3)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<289F,<143C
Melt/Freeze Pt:M.P/F.P Text:39.2F,4.0C
Spec Gravity:1.09-1.52
pH:SUPDAT
Solubility in Water:COMPLETELY SOLUBLE
Appearance and Odor:CLEAR LIQUID W/NO DISTINCT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID DIRECT CONT W/WATER. PROD MAY BE ADDED SLOWLY TO WATER/ACIDS
W/DILUTION & AGITATION TO AVOID VIOLENT (SUPP DATA)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HAZ CARBON MONOXIDE GAS CAN FORM UPON
CONT W/REDUCING SUGARS & FOOD & BEVERAGE PRODS IN ENCLSD SPACES &
CAN CAUSE DEATH.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATL RSLTG FROM CLEAN-UP OPERATIONS MAY BE HAZ
WASTES & THEREFORE, SUBJECT TO SPECIFIC REGS. PACKAGE, STORE,
TRANSPORT & DISP OF ALL CLEAN-UP MATLS & ANY CONTAM EQUIP I/A/W ALL
APPLIC FED, STATE & LOC HLTH & ENVIRON REGS. SHIPMENTS OF WASTE
(ING 17)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CLIPPERSHIP PLASTIC ROOF CEMENT, MP-51
CAGE:1K070
CAGE:1K070
============= Composition/Information on Ingredients =============
Ingred Name:ASPHALT
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: 48-52%
OSHA PEL:N/K
ACGIH TLV:5 MG/M3 (FUME)
Ingred Name:MINERAL SPIRITS (STODDARD)
CAS:64741-41-9
Fraction by Wt: 19-23%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:INTERFIBE 230
Fraction by Wt: 5-7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PA-14 ACETATE
Fraction by Wt: 1-2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MIN-U-GEL AR (CONTAINING INGREDIENT 6)
CAS:8031-18-3
Fraction by Wt: 10-15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CRYSTALLINE SILICA - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:MUSCOVITE
CAS:1318-94-1
Fraction by Wt: 15-17%
OSHA PEL:N/K
Ingred Name:SUPDAT: THROAT & CHEST, CONFUSN, UNCON. HYDROGEN SULFIDE
CONCS OF 1000-2000 PPM CAN BE EXTREMELY HAZ. EVALUATION (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: BASED ON DATA FROM SIMILAR MATLS. INGEST: UNLIKELY
ENTRY ROUTE BUT IF SWALLOWED CONSIDERED PRACTICALLY (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: NON-TOX. ADDNL DATA: IN STUDIES, MICE EXPOS TO
VARIETY OF WHOLE ASPHALTS DID NOT HAVE INCRD CANCER RATE; (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: MICE EXPOS TO ASPHALTS DILUTED W/HYDROCARB SOLVS
HAD INCRD INCIDENCE OF CERTAIN TYPES OF CANCER. BRIEF/ (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:INTERMITTENT SKIN CNTCT W/THIS ASPHALT PROD NOT
EXPECTED TO PRDCE DELAYED EFTS. PROD CNTNS CRYSTALLINE (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: SILICA, A LISTED CARCIN; HOWEVER, PARTICLES ARE
COATED W/ASPHALT & NOT AVAIL FOR INHAL. AS SUCH, THERE (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: IS LITTLE OR NO CHANCE OF INHAL OF CRYSTALLINE
SILICA & RESULTANT DISEASES.
RTECS #:9999999ZZ
Ingred Name:FIRST AID: INHAL:IF THERE ARE SIGNS/SYMPS OF HYDROGEN
SULFIDE EXPOS, MOVE TO FRESH AIR. IF BRTHG STOPS, APPLY (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: ARTF RESP. CALL MD. NOTE TO MD:IN ADDN TO USE OF
100% OXYG & SUPPORTIVE CARE, SUGGESTED TREATMENT FOR (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: HYDROGEN SULFIDE POIS INCLS USE OF NITRITES; BASED
ON SIMILAR MECHANISMS OF TOX BETWEEN HYDROGEN SULFIDE(ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: & HYDROGEN CYANIDE. NITRITE-INDUCED METHEMOGLOBIN
IS THOUGHT TO BIND TOX HYDROSULFIDE ION. INITIAL INHAL(ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: OF AMYL NITRITE PEARLS FOR 15-30 SECONDS OF EACH
MINUTE SHOULD BE INITIATED UNTIL 10 ML OF 3% SOLN OF (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: SODIUM NITRITE CAN BE ADMIN BY IV AT 2.5 TO 5 ML
PER MINUTE. WHILE EFFICACY OF NITRITES IN HYDROGEN (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: SULFIDE POIS HAS NOT BEEN UNEQUIVOCALLY
DEMONSTRATED, USE IS RECOM AS PART OF TREATMENT REGIMEN. (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: HYPERBARIC OXYGEN THERAPY HAS BEEN USED FOR CYANIDE
POIS W/SOME SUCCESS & MAY BE OF BENEFIT IN SULFIDE (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22: POISONING IF OTHER MEASURES INEFTIVE.
INGEST:UNLIKELY; IF OCCURS GIVE MILK/WATER. KEEP HEAD BELOW
WAIST.(ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: CONTACT MD OR POISON CONTROL CENTER. NEVER GIVE
ANYTHING BY MOUTH IF UNCON OR HAVING CONVULSIONS.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE CNTCT: COOL MATL CAUSES MINOR
IRRIT; THERMAL BURNS MAY RSLT FROM CNTCT W/HOT MATL. DEGREE OF
INJURY DEPENDS ON AMT OF MATL THAT GETS INTO EYE & SPEED &
THOROUGHNESS OF FIRST AID. SIGNS & SYMPS MAY INCL:PAIN, TEARS,
SWELL, REDNESS, BLURRED VISION. EVALUATION BASED ON DATA FROM
SIMILAR MATLS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC MONO,
VOL 68, 1997:GROUP 1. NTP 7TH ANNUAL REPORT ON CARCINS, 1994:ANTIC
TO BE CARCIN.
Effects of Overexposure:HLTH HAZ:SYSTEMIC TOX OF SUBSTANCE NOT DETERM.
HOWEVER, IT SHOULD BE PRACTICALLY NON-TOX TO INTERNAL ORGANS IF IT
GETS ON SKIN. INHAL: FUMES FROM HOT MATL CAN BE UNPLEASANT & MAY
PRDCE NAUS & UPPER RE SP TRACT IRRIT. IF INHALED, CONSIDERED
PRACTICALLY NON-TOX TO INTERNAL ORGANS. CNTNS SULFUR CMPDS WHICH
MAY FORM(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH EYES INCL UNDER LIDS W/RUNNING WATER FOR AT LST 15
MIN. GET MED ATTN. SKIN: IF HOT, MELTED MATL GETS ON SKIN, QUICKLY
COOL IN WATER. SEE MD FOR EXTENSIVE BURNS. DO NOT TRY TO PEEL
SOLIDIFIE D MATL FROM SKIN/USE SOLVS/THINNERS TO DISSOLVE. USE OF
VEGETABLE/MINERAL OIL RECOM FOR REMOVAL FROM SKIN. FLUSH EXPOS AREA
W/WATER WHILE REMOVING CONTAM CLTHG. GET MED ATTN IF IRRIT
PERSISTS.(ING 15)
===================== Fire Fighting Measures =====================
Flash Point:110F,43C
Extinguishing Media:WATER, CARBON DIOXIDE AND DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP . USE
WATER SPRAY TO COOL FIRE-EXPOS CNTNRS. FINE WATER MIST MAY BE USED
TO SMOTHER FIRE OR TO DISPERSE (SUPDAT)
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:NOTIFY SAFETY PERSONNEL OF LARGE SPILLS OR
LEAKS. CLEAN UP PERSONNEL NEED PROTECTION AGAINST LIQUID CONTACT
AND VAPOR INHALATION. ABSORB SMALL SPILLS & COLLECT LIQUID, IF
FEASIBLE, OR ABSORB W/VERMICU LITE OR SAND. DO NOT FLUSH TO SEWER
OR STREAM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS IN A COOL,
DRY AND WELL-VENTILATED AREA AWAY FROM OXIDIZERS, HEAT AND OPEN
FLAME. PROTECT CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:CONTACT LENSES POSE A SPECIAL HAZARD; SOFT LENSES MAY
ABSORB AND ALL LENSES CONCENTRATE IRRITANTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . IF
RPTD/PRLNGD CONTACT W/LIQ IS LIKELY, WEAR PROT CLTHG INCL BOOTS,
APRON.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING IMMEDIATELY & DO
NOT REUSE UNTIL IT HAS BEEN PROPERLY LAUNDERED.
Supplemental Safety and Health
FIRE FIGHT PROC: VAPS. DO NOT USE SOLID STREAM OF WATER SINCE STREAM
WILL SCATTER & SPREAD FIRE. EFTS OF OVEREXP: HYDROGEN SULFIDE. ITS
ROTTEN EGGS ODOR IS UNRELIABLE AS INDICATOR OF CONC; SIGNS & SYM PS
OF OVEREXP INCL RESP TRACT IRRIT, HDCH, DIZZ, NAUS, GI DISTURBS,
COUGH, SENSATION OF DRYNESS & PAIN IN NOSE, (ING 8)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:650F,343C
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG OXIDING AGENTS.
Stability Condition to Avoid:THIS MATERIAL IS STABLE IN CLOSED
CONTAINERS AT ROOM TEMPERATURES UNDER NORMAL STORAGE AND HANDLING
CONDITIONS.
Hazardous Decomposition Products:DECOMP PRODS CAN INCL CARBON MONOXIDE,
CARBON DIOXIDE & WATER VAP. CAUTION! HEATING MAY RELS HYDROGEN
SULFIDE GAS(H*2S).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF LIQUID WASTE VIA LICENSED WASTE
DISPOSAL COMPANY. FOLLOW FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ASPHALT EMULSION, RS-1
CAGE:5W738
CAGE:5W738
============= Composition/Information on Ingredients =============
Ingred Name:ASPHALT; (PETROLEUM ASPHALT)
CAS:8052-42-2
RTECS #:CI9900000
Fraction by Wt: 26-65%
OSHA PEL:N/K
ACGIH TLV:5 MG/M3
Ingred Name:SUPDAT:HYGENE PRACT:LEATHER MATL. OBSERVE GOOD PERSONAL
HYGIENE. WASH THORO AFTER WORKING W/ASPHALT & BEFORE EATING.
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:IRRITATION. SKIN:MILD IRRITATION.
REPEATED CONTACT CAN CAUSE DERMATITIS. INHAL:RESPIRATORY
IRRITATION, NAUSEA, DIZZINESS, HEADACHE. INGEST:STOMACH IRRITATION,
NAUSEA, AND VOMITING. BREATHING ASPH ALT AEROSOL OR ASPHALT SMOKE
FOR PROTRACTED PERIODS OF TIME HAS PRODUCED DAM TO THE LUNGS OF
MICE. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:AMONG THE CHANGES OBSERVED WERE
BRONCHITIS, PNEUMONITIS, AND ABSCESS FORMATION. ASPHALT FUME
CONDENSATES HAVE BEEN SHOWN TO PRODUCE A TUMOROGENIC RESPONSE WHEN
REPEATEDLY APPLIED TO THE SKIN OF EXPERIMENTAL ANIMALS. THE
RELEVANCE OF THIS DATA TO HUMANS IS NOT KNOWN AT THIS TIME.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINS
WHILE HOLDING EYELIDS OPEN. GET MED ATTN IF CONDITION PERSISTS.
SKIN:WASH WITH SOAP AND WATER OR USE WATERLESS HANDCLEANER.
INHAL:REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, GIVE OXYGEN;
IF BREATHING HAS STOPPED, GIVE ARTIF RESP. GET MED ATTN. INGEST:IF
VICTIM IS CONSCIOUS, GIVE LIQUIDS. INDUCE VOMITING. CALL A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL, WATER FOG, FOAM CO*2.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY FOAM IF HEATED TO 212F OR IF MIXED
WITH MATERIALS IN EXCESS OF 212F.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL IMMED IN SMALLEST AREA POSS.
RECOVER AS MUCH OF THE PROD AS POSS. RESIDUAL FLUID SHOULD BE
SOAKED UP BY USE OF ABSORBANT MATLS. SWEEP UP & DISPOSE OF IN
ACCORDANCE WITH FEDERAL, STATE & LOCAL REGS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE >180F/USE HEATING SURF
>200F AT SEA LEVEL. SKIN CONT SHOULD BE MINIMIZED. HYDROGEN SULFIDE
IS EXTREMELY FLAMM, HIGHLY TOXIC GAS. (SUPDAT)
Other Precautions:WHEN ASPHALT PRODS ARE HEATED, THEY OFTEN GIVE OFF SM
AMTS OF HYDROGEN SULFIDE. MINIMIZE BRTHG VAPS, FUMES, OR MIST; WHEN
POSS, USE VENT/WORK UPWIND OF SOURCE OF VAPS, FUMES OR MIST.
EXPOSING SKIN TO ASPHALT FUMES, MIST OR VAPS, AS (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQD FOR NORMAL CONDTNS. IF OPERATING
CONDTNS CAUSE HIGH VAP CONCS/TLV IS EXCEEDED, USE NIOSH/MSHA
APPROVED SUPPLIED AIR RESPIRATOR.
Ventilation:NORMAL VENT UNLESS VAPS ARE HIGH, THEN MECH VENT SHOULD BE
USED.
Other Protective Equipment:COMPLETE PROT CLTHG IF MATL IS BEING HANDLED
HOT.
Work Hygienic Practices:CLEAN EXPOSED SKIN W/SOAP & WATER OR WATERLESS
HAND CLEANER. LAUNDER OR DISCARD CONTMD CLTHG. DISCARD CONTAMD (ING
2)
Supplemental Safety and Health
SPEC GRAV:SLIGHTLY >1 (WATER =1). HANDLING/STOR:REFER TO FOLLOW
PUBLICATION ENTITLED "SAFE STORAGE & HNDLG OF HOT ASPHALT"; THE
ASPHALT INSTITUTE, INFORMATION SERIES NO. 180, AUG 1981. OTHER
PREC:MAY OCCUR W/ROAD WORK, CAN INCREASE SENSIT TO SUNBURN. EYE
PROT:SFTY GLASSES W/SFTY SHIELD IF MATL IS COLD.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:SUPDAT
Evaporation Rate & Reference:NO DATA AVAILABLE
Solubility in Water:DILUTES WITH WATER
Appearance and Odor:BROWN TO BLACK LIQUID OR SEMISOLID
Percent Volatiles by Volume:30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HEAT, FLAME OR SPARK. DO NOT HEAT TO
BOILING POINT - 212F.
Hazardous Decomposition Products:HAZARDOUS GASES/VAPORS PRODUCED ARE
CARBON DIOXIDE, CARBON MONOXIDE, OR SULFUR DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE AS MUCH OF RECOVERABLE PROD AS POSS.
DISPOSE OF NONRECYCLABLE MATL BY SUCH METHS AS CONTROLLED
INCINERATION/BLENDING W/AGGREGATE & USED FOR PATCHING & OTHER
MAINTENANCE USE. DISPOSE OF IN ACCO RDANCE WITH FEDERAL, STATE AND
LOCAL REGS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:THREE STAR LATEX FLAT HOUSE PAINT - WHITE, 131A100
CAGE:ACEHA
CAGE:ACEHA
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 9.3%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CLAY (KAOLIN); (ALUMINUM SILICATE)
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 9.3%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:NEPHELINE SYENITE
CAS:37244-96-5
Fraction by Wt: 9.3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, AMORPHOUS, DIATOMACEOUS EARTH; (DIATOMACEIOUS
SILICA)
CAS:61790-53-2
RTECS #:HL8600000
Fraction by Wt: 2.2%
OSHA PEL:20 MPPCF
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:1-PROPANOL, 2-AMINO-2-METHYL-;
(2-AMINO-2-METHYL-1-PROPANOL)
CAS:124-68-5
RTECS #:UA5950000
Fraction by Wt: 0.2%
OSHA PEL:20 PPM (MFR)
ACGIH TLV:10 PPM (MFR)
Ingred Name:AMMONIA (SARA 302/313) (CERCLA)
CAS:7664-41-7
RTECS #:BO0875000
Fraction by Wt: <0.1%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM; 35 STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IN A CONFINED AREA VAPORS IN
HIGH CONCENTRATION ARE ANESTHETIC. IRRITANT TO UPPER RESPIRATORY
SYSTEM. CHRONIC PROBLEMS WITH RESPIRATORY SYSTEM MAY BE AGGRAVATED
BY EXPOSURE TO VAPORS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:LIGHTHEADEDNESS AND STAGGERED GAIT.
Medical Cond Aggravated by Exposure:CHRONIC PROBLEMS WITH RESPIRATORY
SYSTEM MAY BE AGGRAVATED BY EXPOSURE TO VAPORS.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE FROM EXPOSURE -
RESTORE BREATHING - KEEP WARM AND QUIET. SKIN: WASH FROM SKIN WITH
SOAP AND WATER. EYES: FLUSH EYES WITH WATER FOR AT LEAST 15 MINUTES
. GET MEDICAL AID. LAUNDER CONTAMINATEDCLOTHING BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:199F,93C
Extinguishing Media:NON-COMBUSTIBLE - FOR DRY SOLIDS USE WATER, FOAM,
CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO EXTREME HEAT
MAY RUPTURE DUE TO PRESSURE BUILDUP. CONTENTS MAY SPATTER IF
TEMPERATURE EXCEEDS 212F.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DOL STORAGE CATEGORY 3B.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DEVICE APPROVED BY NIOSH.
Ventilation:LOCAL EXHAUST PREFERABLE. MECHANICAL (GENERAL): ACCEPTABLE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:AVOID BREATHING VAPOR OR SPRAY MIST. AVOID
CONTACT WITH SKIN OR EYES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Density:HVR/AIR
Spec Gravity:1.27 (H*2O=1)
Evaporation Rate & Reference:SLOWER/ETHER (BU AC=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE PIGMENTED PASTE WITH SLIGHT AMMONIA ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO HAZARDOUS REACTIONS ARE EXPECTED UNDER NORMAL USE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ATOM ARC LOW HYDROGEN WELDING ELECTRODES
CAGE:84021
CAGE:84021
============= Composition/Information on Ingredients =============
Ingred Name:MAGNESIUM
CAS:7439-95-4
RTECS #:OM2100000
Fraction by Wt: 1-2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 AS MGO FUME
ACGIH TLV:10 MG/M3 AS MGO FUME
Ingred Name:NICKEL (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 1-2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9596
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:CALCIUM FLUORIDE (AS F)/FLUORSPAR
CAS:7789-75-5
RTECS #:EW1760000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2.5 MG/M3 AS F
ACGIH TLV:2.5 MG/M3 AS F
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:SILICATE BINDERS
CAS:10006-28-7
Other REC Limits:NONE RECOMMENDED
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:MINERAL SILICATES
CAS:1332-58-7
Other REC Limits:NONE RECOMMENDED
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM.
ACGIH TLV:10 PPM.
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 (TDUST)
ACGIH TLV:5 MG/M3 (OXIDE FUME)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY INCLUDE IRRITATION OF EYES,
LUNGS, NOSE & THROAT. SOME GASES ASSOCIATED WITH WELDING MAY CAUSE
PULMONARY EDEMA, ASPHYXIATION AND DEATH.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:WATERY EYES, NOSE/THROAT IRRITATION, HEADACHE,
DIZZINESS, DIFFICULTY IN BREATHING, FREQUENT COUGHING, CHEST PAIN.
THE PRESENCE OF NICKEL COMPOUNDS IN FUME CAN CAUSE METALLIC TASTE,
NAUSEA, TIGHTNESS O F CHEST, FEVER AND ALLERGIC REACTION.
Medical Cond Aggravated by Exposure:INDIVIDUALS W/ALLERGIES OR IMPARIED
RESPIRATORY FUNCTION MAY HAVE SYMPTOMS WORSENED BY EXPO TO WELDING
FUMES. HOWEVER SUCH RX CAN'T BE PREDICTED DUE TO VARIATION IN
COMPOSITION/QUANT OF DECOMP PRODUCT
======================= First Aid Measures =======================
First Aid:IN CASE OF EMERGENCY CALL FOR MEDICAL AID. EMPLOY FIRST AID
TECHNIQUE RECOMMENDED BY RED CROSS. IF BREATHING IS DIFFICULT, GIVE
OXYGEN & CALL FOR A PHYSICIAN. FOR ELECTRIC SHOCK, DISCONNECT/TURN
OFF P OWER. IF NOT BREATH BEGIN ARTIFICIAL RESPIRATION, PREFERABLY
MOUTH-TO-MOUTH. IF NO DETECTABLE PULSE, BEGIN CPR. IMMEDIATELY CALL
A PHYSICIAN. FOR ARC BURN, APPLY COLD, CLEAN COMPRESSES/CALL
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:USE EXTINGUISHING MEDIA RECOMMENDED FOR BURNING
MATERIALS & FIRE SITUATION.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:ONLY THE PACKAGING FOR THIS PRODUCT WILL
BURN. PRODUCT WON'T BURN. HOWEVER WELDING ARC/SPARKS CAN IGNITE
COMBUSTIBLES AND FALAMMABLE MATERIALS.
======================Handling and Storage ======================
Handling and Storage Precautions:READ AND UNDERSTAND MANUFACTURERS
INSTRUCTIONS AND PRECAUTIONARY LABELS. SEE 29CFR1910.
Other Precautions:AS SHIPPED PRODUCT IS NONFLAMMABLE, NONEXPLOSIVE,
NONREACTIVE, NONHAZARDOUS. REF:ANSI Z49.1 "SAFETY IN
WELD/CUT"/ANSI/AWS F1.1.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN WELDING IN CONFINED SPACE OR WHERE LOCAL
EXHAUST/VENTILATION DOES NOT KEEP EXPO BELOW TLV.
Ventilation:USE ENOUGH VENTILATIO/LOCAL EXHAUSTAT THE ARC TO KEEP
FUME/GAS BEL TLV IN WORKER BREATH ZONE/GENERAL WORK AREA.
NECESSARY TO SHIELD OTHERS. WEAR HEAD/HAND/BODY
PROTECTION-ARM/SHOULDER.
Work Hygienic Practices:TRAIN WELDER NOT TO TOUCH LIVE ELCTRICAL PARTS/
INSULATE HIMSELF FROM WORK/GROUND.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NP
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:NP
Vapor Density:NP
Spec Gravity:NP
pH:NP
Viscosity:NP
Evaporation Rate & Reference:NP
Solubility in Water:NP
Appearance and Odor:SOLID, FLUX COATED STEEEL CORE WIRE, ODORLESS.
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE CURRENTLY KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES CANNOT BE CLASSIFIED
SIMPLY. THE COMPOSITION AND QUANTITY OF BOTH ARE DEPENDENT UPON THE
MATERIAL WORKED.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT/RESIDUE/DISPOSE OF CONTAINER LINER
IN ENVIRONMENTALLY ACCEPTABLE MANNER IN FULL COMPLIANCE WITH
FEDERAL, STATE AND LOCAL R EGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FLUORODYNE, LS-400
CAGE:58215
CAGE:58215
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENTS
Fraction by Wt: >99%
OSHA PEL:N/K
ACGIH TLV:100 (MFR)
Ingred Name:ADDITIVES
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) 4.8 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF MUCOUS MEMBRANES,
EXCITEMENT, DEPRESSION. MAY CAUSE MILD MACROCYTIC ANEMIA BUT NOT
LEUKOPENIA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) . EYES: IMMEDIATELY FLUSH W/POTABLE
WATER FOR A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD . SKIN:
TH OROUGHLY WASH EXPOSED AREA WITH SOAP AND WATER. INGEST: DO NOT
INDUCE VOMITING. KEEP WARM, QUIET AND GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:124F,51C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG GROUND OR BE MOVED BY VENTILATION AND IGNITED BY
FLAME. NEVER USE WELDING TORCH ON DRUMS.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER WITH ABSORBENT MATERIAL TO CONFINE SPILL
AND SWEEP OR SHOVEL INTO CONTAINER. AVOID BREATHING VAPORS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EXCESSIVE HEAT, SPARKS AND OPEN
FLAME. KEEP CONTAINERS CLOSED.
Other Precautions:ALL HAZARD PRECAUTIONS GIVEN IN MSDS APPLY TO EMPTY
CONTAINERS ALSO.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING
APPARATUS WITH FULL FACEPIECE.
Ventilation:USE UNDER HOOD. USE ONLY WITH ADEQUATE VENTILATION. NO
SMOKING OR OPEN LIGHTS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . TO
PREVENT REPEATED OR PROLONGED CONTACT WEAR IMPERVIOUS CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SOL IN H*2O: MISCIBLE WITH SMALL QUANTITIES OF WATER. CLOUDS &
SEPARATES IN LARGE QUANTITIES OF WATER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>348F,>176C
Vapor Pres:2.0 @ 25C
Vapor Density:4.8
Spec Gravity:0.91 (H*2O=1)
Evaporation Rate & Reference:<0.1
Solubility in Water:SUPDAT
Appearance and Odor:CLEAR, COLORLESS LIQUID; SLIGHT AROMATIC ODOR.
Percent Volatiles by Volume:>99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
VARIOUS HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . BY INCINERATION OR DEPOSIT IN POSTED
ORGANIC SOLVENT LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WATER MASTER WATERBORNE TOP COAT, 15TC, SPRAYABLE, SEMIGLOSS
CAGE:0ZXD0
CAGE:0ZXD0
============= Composition/Information on Ingredients =============
Ingred Name:DIPROPYLENE GLYCOL MONOMETHYL ETHER (SARA III)
CAS:34590-94-8
RTECS #:JM1575000
Fraction by Wt: 2.25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM (SKIN)
ACGIH TLV:100 PPM (SKIN)
Ingred Name:PROPYLENE GLYCOL MONO-TERT-BUTYL ETHER
CAS:57018-52-7
Fraction by Wt: 4.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPYLENE GLYCOL N-BUTYL ETHER
CAS:5131-66-8
RTECS #:UA7700000
Fraction by Wt: 2.25%
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOLATILE ORGANIC CONTENT (VOC): 222.62 GRAMS/LITER MINUS
WATER. 1.86 POUNDS/GALLON.
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
Ingred Name:TOTAL VOLATILE EMISSIONS: 0.79 POUNDS/GALLON. 95.01
GRAMS/LITER.
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYE: SEVERE IRRITATION FROM CONTACT.
SKIN: SLIGHT IRRITATION UPON REPEATED/PROLONGED CONTACT.
INHALATION: EXTREMELY HIGH CONCENTRATIONS IRRITATING TO EYES AND
RESPIRATORY TRACT. SIGNS & SYMPTOMS OF TO XICITY SIMILAR TO
SWALLOWING. SWALLOWING: HEADACHE, DIZZINESS, INCOORDINATION,
NAUSEA, VOMITING, DIARRHEA, GENERAL *
Effects of Overexposure:* WEAKNESS. INGESTION OF SIGNIFICANT QUANTITIES
MAY RESULT IN RED BLOOD CELL HEMOLYSIS.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE AN EXISTING
DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH EYES THOROUGHLY WITH WATER AND
CONTINUE WASHING SEVERAL MINUTES. OBTAIN MEDICAL ATTENTION. SKIN:
REMOVE CONTAMINATED CLOTHING. FLUSH SKIN WITH WATER. INHALATION:
REMOVE TO FRES H AIR. SWALLOWING: IF PATIENT IS CONSCIOUS AND HAS A
GAG REFLEX, GIVE TWO GLASSES OF WATER. INDUCE VOMITING. OBTAIN
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:TYPE A, B, C, OR COMBINATION TYPE
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AND CONTAIN SPILLS. ABSORB WITH SUITABLE
MATERIAL. COLLECT MATERIAL INTO SUITABLE CONTAINERS AND DISPOSE OF
PROPERLY.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT ALLOW PRODUCT TO FREEZE! DO NOT
STORE BELOW 40F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ADEQUATE VENTILATION IS NOT MAINTAINED,
RESPIRATORS (OSHA/NIOSH APPROVED) MAY BE NECESSARY. IF EXPOSURE TO
SPRAY MISTS EXISTS, WEAR NIOSH APPROVED ORGANIC VAPOR/PARTICULATE
RESPIRATOR.
Ventilation:LOCAL EXHAUST VENTILATION IS RECOMMENDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:304F,151C
Vapor Density:< AIR
Spec Gravity:1.008 (WATER=1)
Evaporation Rate & Reference:LESS THAN 1 (BU AC=1)
Solubility in Water:DILUTABLE
Appearance and Odor:CLEAR OR COLORED LIQUID, SLIGHT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL,
COUNTY, STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TT-E-47F
CAGE:60806
CAGE:60806
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENTS
Fraction by Wt: 57.5%
ACGIH TLV:1000PPM
Ingred Name:VEHICLE
Fraction by Wt: 14.0%
ACGIH TLV:1000PPM
Ingred Name:SOLVENTS
Fraction by Wt: 27.3%
ACGIH TLV:300PPM
Ingred Name:ADDITIVES
Fraction by Wt: 1.2%
ACGIH TLV:1000PPM
===================== Hazards Identification =====================
Effects of Overexposure:SKIN IRRITANT.INHAL:HEADACHE,DIZZY,EYE
IRRITATION.
======================= First Aid Measures =======================
First Aid:DO NOT INDUCE VOMIT IF INGESTED. EYES/SKIN:FLUSH WITH
WATER.CALL DR.
===================== Fire Fighting Measures =====================
Flash Point:135F,53C CC
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:CO*2 FOAM DRY CHEM
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN SPILLAGE WITH RAGS.SAWDUST.OR SAND
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT TEMP.ABOVE 0F.-17.8C AND
BELOW 115F 46.1 C.CAUTION COMBUSTIBLE LABEL KEEP AWAY FROM
CHILDREN.
Other Precautions:DO NOT STORE NEAR OPEN FLAME OR HIGH HEAT.USE WITH
ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:LOCAL EXHAUST,FAN.
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Vapor Pres:10
Vapor Density:4.9
Spec Gravity:1.46
Evaporation Rate & Reference:<BUTYL AC
Solubility in Water:0.0
Appearance and Odor:CREAMY LIGHT GREEN LIQUID SOLVENT ODOR.
Percent Volatiles by Volume:50.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NATURAL RUBBER
Stability Condition to Avoid:TEMP.<0F.-17.8C AND ABOVE 115F 46.1C
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN CLOSED CONTAINERS AWAY FROM OPEN
FLAME AND HIGH HEAT.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:RA PID GRO TOMATO-VEG FOOD 18-21-21
CAGE:0AHD1
CAGE:0AHD1
CAGE:96004
============= Composition/Information on Ingredients =============
Ingred Name:UREA
CAS:57-13-6
RTECS #:YR6250000
Ingred Name:AMMONIUM PHOSPHATE MONOBASIC
CAS:7722-76-1
Ingred Name:AMMONIUM HYDROGEN PHOSPHATE
CAS:7783-28-0
Ingred Name:POTASSIUM NITRATE
CAS:7757-79-1
RTECS #:TT3700000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION/VISUAL DISTURBANCES.
INHALATION: DUST MAY BE IRRITATING TO RESPIRATORY TRACT, HEADACHE,
NAUSEA, VOMITING, CONFUSION, DIZZINESS, CYANOSIS, COMA, BRONCHITIS,
COUGHING, PULMONARY EDEMA, D IFFICULTY IN BREATHING, & GIDDINESS.
SKIN: IRRITATION. INGESTION: MAY BE TOXIC.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION/VISUAL DISTURBANCES.
APPLICATION OF SIMILAR MATERIAL INTO THE EYES OF RABBITS PRODUCED
SLIGHT TO MODERATE MEMBRANE IRRITATION W/O CORNEAL INJURY.
INGESTION: MAY BE HARMFUL. INHALATION : DUST MAY BE IRRITATING TO
THE RESPIRATORY TRACT, NASAL DISCHARGE, SORE THROAT, COUGHING,
BRONCHITIS, PULMONARY EDEMA.
Medical Cond Aggravated by Exposure:DECREASED HEART RATE & REDUCED
BLOOD PRESSURE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINUTES. SEE DOCTOR.
SKIN: WASH THOROUGHLY W/WATER. LAUNDER CONTAMINATED CLOTHING.
INHALATION: MOVE PERSON TO FRESH AIR. SEE DOCTOR. INGESTION: GIVE
WATER OR MILK T O DRINK & GET MED ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER
Fire Fighting Procedures:DON'T ENTER ANY ENCLOSED/CONFINED FIRE SPACE
W/O PROPER PROTECTIVE EQUIPMENT, INCLUDING SELF-CONTAINED BREATHING
APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP SPILLS, OBSERVING PRECAUTIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T APPLY DIRECTLY TO WATER. DON'T
CONTAMINATE WATER BY CLEANING OF EQUIPMENT OR DISPOSAL OF WASTE.
Other Precautions:DON'T GET IN EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF OPERATING CONDITIONS CREATE AIRBORNE
CONCENTRATIONS WHICH EXCEED TLV, THE USE OF AN APPROVED RESPIRATOR
IS RECOMMENDED.
Ventilation:USE ADEQUATE VENTILATION TO KEEP THE AIRBORNE
CONCENTRATIONS <TLV.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
pH:6.8
Solubility in Water:COMPLETE
Appearance and Odor:GREEN OR ORANGE POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCING OR OXIDIZING AGENTS, COPPER, BRASS, STEEL & CONCRETE
Hazardous Decomposition Products:AMMONIA, HYDROGEN CHLORIDE, OXIDES OF
NITROGEN, PHOSPHORUS & SULFUR
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN A MANNER
CONSISTANT W/APPLICABLE REGULATIONS. IF SAFE & PRACTICABLE, RECLAIM
MATERIAL. DON'T CONTAMINATE WATER BY DISPOSAL. DON'T CONTAMINATE
WATER BY CLEANING OF EQUIP MENT OR DISPOSAL OF WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CHLOROFORM, 4434
Resp. Party Other MSDS Num.:C2915
CAGE:70829
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:CHLOROFORM
CAS:67-66-3
RTECS #:FS9100000
Minumum % Wt:98.
Maxumum % Wt:100.
Other REC Limits:N/K
OSHA PEL:C240 MG/M3;C50 PPM
OSHA STEL:N/K
ACGIH TLV:49 MG/M3;10 PPM
ACGIH STEL:N/K
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:ETHYL ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
Minumum % Wt:0.
Maxumum % Wt:1.
Other REC Limits:N/K
OSHA PEL:1900 MG/M3;1000 PPM
OSHA STEL:N/K
ACGIH TLV:1880 MG/M3;1000 PPM
ACGIH STEL:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE TOXICOLOGICAL INFORMATION.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: ACTS AS A
RELATIVELY POTENT ANESTHETIC. IRRITATES RESPIRATORY TRACT AND
CAUSES CENTRAL NERVOUS SYSTEM EFFECTS, INCLUDING HEADACHE,
DROWSINESS, DIZZINESS. EXPOSURE TO HIGHER CONCENTR ATIONS MAY
RESULT IN UNCONSCIOUSNESS & EVEN DEATH. MAY CAUSE LIVER INJURY AND
BLOOD DISORDERS. PROLONGED EXPOSURE MAY LEAD TO DEATH DUE TO
IRREGULAR HEART BEAT AND KIDNEY AND LIVER DISORDERS. INGESTIO N:
CAUSES SEVERE BURNING IN MOUTH AND THROAT, PAIN IN THE CHEST AND
VOMITING. LARGE QUANTITIES MAY CAUSE SYMPTOMS SIMILAR TO
INHALATION. SKIN: CAUSES SKIN IRRITATION RESULTING IN REDNESS AND
PAIN. (EF FECTS OF OVEREXPOSURE)
Explanation of Carcinogenicity:CHLOROFORM: IARC MONOGRAPHS, SUPPLEMENT,
VOLUME 7, PAGE 152, 1998: GROUP 2B. NTP 8TH ANNUAL REPORT ON
CARCINOGENS, 1998: REASONABLY ANTICIPATED TO BE HUMAN CARCINOGEN.
HUMAN: LIVER/KIDNEY TUMORS, CENT RAL NERVOUS SYSTEM EFFECTS.
Effects of Overexposure:HEALTH HAZARDS: REMOVES NATURAL OILS. MAY BE
ABSORBED THROUGH THE SKIN. EYES: VAPORS CAUSE PAIN AND IRRITATION
TO EYES. SPLASHES MAY CAUSE SEVERE IRRITATION AND POSSIBLE EYE
DAMAGE. CHRONIC: PROLONGEDOR REPEATED EXPOSURE TO VAPORS MAY
CAUSE DAMAGE TO THE NERVOUS SYSTEM, THE HEART, THE LIVER, AND THE
KIDNEYS. CONTACT WITH LIQUID HAS DEFATTING EFFECT AND MAY CAUSE
CHRONIC IRRITATION OF SKIN WITH CR ACKING AND DRYING, AND
CORRESPONDING DERMATITIS. CHLOROFORM IS A SUSPECTED HUMAN
CARCINOGEN.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR EYE PROBLEMS, OR IMPAIRED LIVER, KIDNEY OR RESPIRATORY
FUNCTION MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THE SUBSTANCE.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP. IF
BRTHG IS DFCLT, GIVE OXYGEN. GET MED ATTN. INGEST: DO NOT INDUCE
VOMIT. GIVE LGE QTYS OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCON PE RS. GET MED ATTN IMMED. SKIN: IMMED FLUSH W/PLENTY OF
WATER FOR AT LEAST 15 MINS WHILE REMOVING CONTAM CLTHG & SHOES. GET
MED ATTN IMMED. WASH CLTHG BEFORE REUSE. THORO CLEAN SHOES BEFORE
REUSE. EYES: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS,
LIFTING LOWER & UPPER LIDS OCCAS. GET MED ATTN IMMED. NOTE TO MD:
BECAUSE KIDNEY & LIVER EFTS MAY BE DELAYED, KEEP VICTIM UNDER
OBSERVATION FOR 24- 48 HRS. (SUP DAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:USE ANY MEANS SUITABLE FOR EXTINGUISHING
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:SLIGHT FIRE HAZARD WHEN EXPOSED TO HIGH
HEAT. OTHERWISE, PRACTICALLY NOT FLAMMABLE. SEALED CONTAINERS MAY
RUPTURE WHEN HEATED.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. WEAR APPROP PERS PROT EQUIP AS
SPECIFIED IN CTL MEASURES SECTION. ISOLATE HAZ AREA. KEEP UNNEC &
UNPROTECTED PERS FROM ENTERING. CONTAIN & RECOVER LIQ WHEN POSS.
COLLECT LIQ IN APPROP CONTR /ABSORB W/INERT MATL (E.G.,
VERMICULITE, DRY SAND, ETC), & PLACE IN CHEM WASTE CONTR. DO NOT
USE COMBUST MATLS, SUCH AS SAWDUST. DO NOT FLUSH TO SEWER! US REGS
(CERCLA) REQUIRE REPORTING (OTHER INFO)
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN TIGHTLY CLSD LIGHT-RESIST
CONTR, STORED IN COOL, DRY, VENTILATED AREA. PROTECT AGAINST
PHYSICAL DMG. ISOLATE FROM INCOMPATIBLE SUBSTANCES. WEAR SPECIAL
PROT EQUIP (CTL MEASURES SECTION) FOR MA INT BREAK-IN/WHERE EXPOS
MAY EXCEED ESTABLISHED EXPOS LEVELS.
Other Precautions:CONTRS OF THIS MATL MAY BE HAZ WHEN EMPTY SINCE THEY
RETAIN PROD RESIDUES (VAPS, LIQS); OBSERVE ALL WARNINGS & PREC
LISTED FOR PROD. CHLOROFORM ODOR THRESHOLD: 250 MG/M3. ODOR
THRESHOLD ONLY SERVES AS WARNING OF EXPOS; NOT SMELLING IT DOES
NOT MEAN YOU ARE NOT BEING EXPOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF THE EXPOSURE LIMIT IS EXCEEDED, WEAR A NIOSH
APPROVED SUPPLIED AIR, FULL-FACEPIECE RESPIRATOR, AIRLINED HOOD, OR
FULL-FACEPIECE SELF-CONTAINED BREATHING APPARATUS. THIS SUBSTANCE
HAS POOR WARNING P ROPERTIES.
Ventilation:A SYS OF LOC &/OR GEN EXHST IS REC TO KEEP EMPLOYEE EXPOS
BELOW AIRBORNE EXPOS LIMS. LOC EXHST VENT IS GEN PREF BECAUSE IT
CAN CTL EMISSIONS OF (TRANSPORT INFO)
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . WEAR IMPERVIOUS PROTECTIVE CLOTHING, INCLUDING BOOTS, LAB
COAT, APRON OR COVERALLS, AS APPROPRIATE, TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS, FACE, FOREARMS & NECK WHEN EXITING
RESTRICTED AREAS. SHOWER, DISPOSE OF OUTER CLTHG, CHANGE TO CLEAN
GARMENTS AT END OF DAY. AVOID CROSS-CONTAM OF STREET CLOTHES.
(STATE REGS)
Supplemental Safety and Health
FIRST AID PROC: ADMIN OF FLUIDS MAY HELP TO PVNT KIDNEY FAILURE. OBTAIN
BLOOD GLUCOSE, URINALYSIS, LIVER FUNC TESTS, CHEST X-RAY, & MONITOR
CARD FUNC & FLUID/ELECTROLYTE STATUS. MONITOR LIVER & KIDNEY FUNC
FOR 4-5 DAYS AFTER EXPOS. DISULFIRAM, ITS METABOLITES, & HIGH
CARBOHYDRATE DIET APPEAR TO PROTECT (OTHER INFO)
================== Physical/Chemical Properties ==================
Boiling Pt:=62.2C, 144.F
Melt/Freeze Pt:=-63.9C, -83.F
Vapor Pres:160 MM HG @ 20C (68F)
Vapor Density:4.1(AIR=1)
Spec Gravity:1.48 @ 20C/4C
Evaporation Rate & Reference:11.6 (BUTYL ACETATE=1)
Solubility in Water:0.8G/100G WATER @ 20C/68F
Appearance and Odor:CLEAR, COLORLESS LIQUID, WITH CHARACTERISTIC
ETHEREAL ODOR.
Percent Volatiles by Volume:100 @ 21C
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG CAUSTICS AND CHEMICALLY-ACTIVE METALS SUCH AS ALUMINUM,
MAGNESIUM POWDER, SODIUM, OR POTASSIUM; ACETONE, FLUORINE,
METHANOL, SODIUM METHOXIDE, DINITROGEN TETROXIDE, TERT-BUTOXIDE,
TRIISOPROPYLPHOSPHINE.
Stability Condition to Avoid:PH DECREASES ON PROLONGED EXPOSURE TO
LIGHT AND AIR DUE TO FORMATION OF HCL. AVOID LIGHT, HEAT, AIR AND
INCOMPATIBLES.
Hazardous Decomposition Products:MAY PRODUCE CARBON MONOXIDE, CARBON
DIOXIDE, HYDROGEN CHLORIDE AND PHOSGENE WHEN HEATED TO
DECOMPOSITION.
=================== Toxicological Information===================
Toxicological Information:CHLOROFORM: ORAL RAT LD50: 908 MG/KG; SKIN
RABBIT LD50: >20 GM/KG; INHAL RAT LC50: 47702 MG/M3/4H; IRRIT DATA:
SKIN RABBIT: 10 MG/24H OPEN MILD; EYE RABBIT: 20 MG/24H MOD;
INVESTIGATED AS TUMORIGEN, M UTAGEN, REPRO EFFECTOR. REPRO
TOXICITY: BIRTH DEFECTS HAVE BEEN SEEN IN RATS & MICE EXPOSED BY
INHAL OF CHLOROFORM AT CONCS >100 PPM IN AIR. INGEST OF CHLOROFORM
BY PREGNANT LAB ANIMALS HAS RESULTED I N FETOTOXICITY BUT NOT BIRTH
DEFECTS, & ONLY AT LEVELS CAUSING SEV MATERNAL EFTS. OTHER INFO:
LAB PROT EQUIP: GOGGS & SHIELD, LAB COAT & APRON, VENT HOOD, PROPER
===================== Ecological Information =====================
Ecological:WHEN RELEASED INTO SOIL, THIS MATL IS EXPECTED TO LEACH INTO
GROUNDWATER, & QUICKLY EVAPORATE. WHEN RELEASED INTO WATER, THIS
MATL IS EXPECTED TO QUICKLY EVAPORATE, & HAVE A HALF-LIFE BETWEEN 1
& 10 D AYS. THIS MATL HAS A LOG OCTANOL-WATER PARTITION COEFFICIENT
OF <3.0. THIS MATL IS NOT EXPECTED TO SIGNIFICANTLY BIOACCUMULATE.
WHEN RELEASED INTO AIR, THIS MATL MAY BE MOD DEGRADED BY RXN
W/PHOTOCHEM ICALLY-PRDCED HYDROXYL RADICALS, & BY PHOTOLYSIS. WHEN
RELEASED INTO AIR, THIS MATL MAY BE REMOVED FROM ATM TO MOD EXTENT
BY WET DEPOSITION. (SARA REGS)
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECOVERY/RECYCLING
SHOULD BE HANDLED AS HAZ WASTE & SENT TO RCRA APPROVED WASTE
FACILITY. PROCESSING, USE/CONTAMINATION OF PROD MAY CHANGE WASTE
MANAGEMENT OPTIONS. STATE & LOCAL DISP REGULATIONS MAY DIFFER FROM
FEDERAL DISPOSAL REGULATIONS. DISPOSE OF CONTAINER & UNUSED
CONTENTS I/A/W FEDERAL, STATE & LOC REQUIREMENTS.
=================== MSDS Transport Information ===================
Transport Information:DOMESTIC (LAND, D.O.T.): PROPER SHIPPING NAME:
RQ, CHLOROFORM; HAZ CLASS: 6.1; UN/NA: UN1888; PACKING GROUP: III;
INFO REPORTED FOR PROD/SIZE: 24.5 L. INTERNATIONAL (WATER, I.M.O.):
PROPER SHIPPING NA ME: CHLOROFORM; HAZ CLASS: 6.1; UN/NA: UN1888;
PACKING GROUP: III; INFO REPORTED FOR PROD/SIZE: 24.5 L. VENT:
CONTAMINANT AT ITS SOURCE, PREVENTING DISPERSION OF IT INTO GEN
WORK AREA. PLEASE REFER TOACGIH DOCUMENT, INDUS VENT, A MANUAL OF
RECOMMENDED PRACTICES, MOST RECENT EDITION, FOR DETAILS.
===================== Regulatory Information =====================
SARA Title III Information:CHLOROFORM (67-66-3): SARA 302 RQ: 10; SARA
302 TPQ: 10000; LISTED IN SARA 313; NOT LISTED IN SARA 313 CHEMICAL
CATEGORIES. ETHYL ALCOHOL (64-17-5): NOT LISTED IN SARA RQ/TPQ,
SARA 313 LIST, SARA 313 CHEMICAL CATEGORIES. SARA 311/312: ACUTE:
YES; CHRONIC: YES; FIRE: NO; PRESSURE: NO; REACTIVITY: NO
(MIXTURE/LIQUID). ECOLOGICAL INFO: WHEN RELEASED INTO AIR, THIS
MATERIAL IS EXPECTED TO HAVE A HALF- LIFE OF >30 DAYS.
ENVIRONMENTAL TOXICITY: THIS MATERIAL IS NOT EXPECTED TO BE TOXIC
TO AQUATIC LIFE. LC50/96-HR VALUE FOR FISH ARE >100 MG/L.
Federal Regulatory Information:CHLOROFORM (67-66-3)/ETHYL ALCOHOL
(64-17-5): LISTED IN TSCA, EC, JAPAN, AUSTRALIA, KOREA, CANADA DSL,
THE PHILLIPINES; NOT LISTED IN CANADA NDSL. CHLOROFORM (67-66-3):
CERCLA: 10; RCRA 261.33: U044; TSCA 8 (D): NO. ETHYL ALCOHOL
(64-17-5): NOT LISTED IN CERCLA, RCRA 261.33, TSCA 8 (D). CHEMICAL
WEAPONS CONVENTION: NO. TSCA 12 (B): NO. CDTA: NO. AUSTRALIAN
HAZCHEM CODE: 2Z. POISON SCHEDULE: S6. WH MIS: THIS MSDS HAS BEEN
PREPARED ACCPRDING TO THE HAZARD CRITERIA OF THE CONTROLLED
PRODUCTS REGULAT IONS (CPR) AND THE MSDS CONTAINS ALL OF THE
INFORMATION REQUIRED BY THE CPR.
State Regulatory Information:WARNING: THIS PRODUCT CONTAINS A CHEMICAL
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER. HYGIENE
PRACTICES: WASH HANDS BEFORE EATING AND DO NOT EAT, DRINK, OR SMOKE
IN WORKPLACE. DO NOT BREATHE VAP OR. DO NOT GET IN EYES, ON SKIN,
OR ON CLOTHING. KEEP CONTAINER CLOSED. USE WITH ADEQUATE
VENTILATION. WASH THOROUGHLY AFTER HANDLING.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:762 HAI-233 RF 95/70, NICKEL ALLOYS
CAGE:49076
CAGE:49076
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL; (NI) (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: +99%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:OTHER PROT EQUIP:AWS PUBLICATION F2.2.
RTECS #:9999999ZZ
WELDING.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:UNDER NORMAL HNDLG/USE, SOLID ALLOY
PRESENTS FEW HAZARDS. THEY MAY INCLUDE SKIN IRRIT/OTHER ALLERGIC
REACTIONS IN SENSIT INDIVIDUALS. DUST/FUMES/GASES MAY CAUSE:
ACUTE:NAUSEA, TIGHTNESS OF CHEST, FEVE R, IRRITATION OF EYES, NOSE,
THROAT & SKIN; LOSS OF CONSCIOUSNESS DUE TO WELDING GASES OR LACK
OF O2. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL:IARC GROUP 2B, NTP ANTICIPATED TO
BE A CARCINOGEN.
Effects of Overexposure:HLTH HAZ:CHRONIC:ADVERSE EFFECTS MAY INCLUDE
SKIN SENSITIZATION, NEUROLOGICAL DMG & RESPIRATORY DISEASES
(BRONCHIAL ASTHMA, LUNG FIBROSIS/PNEUMOCONIOSIS).
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:NOT APPLICABLE. EYES:IMMEDIATELY FLUSH WITH POTABLE
WATER FOR A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD .
SKIN:NOT APPLICABLE. INHAL:REMOVE FROM EXPOSURE AND OBTAIN PROMPT
MEDICAL ATTENTION. ADMINISTER OXYGEN IF VICTIM IS UNCONSCIOUS. IF
NOT BREATHING, RESUSCITATE IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:NONE. WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATERIAL IS UNFLAMMABLE; HOWEVER, WELDING
ARCS AND SPARKS CAN IGNITE FLAMMABLE LIQUIDS AND VAPORS AND
COMBUSTIBLE SOLIDS.
================== Accidental Release Measures ==================
Spill Release Procedures:UNDER NORMAL HNDLG & USE, MATL IS NOT
VOLATILE/DUSTY & DOES NOT PRESENT SPILLAGE & LEAKAGE PROBLEMS. NO
PROTECION REQUIRED, EXCEPT AVOID PRLNGD/RPTD DIRECT SKIN CONT IF
SENSITIVE TO METALS. IF HOWEVER , MATL IS RELEASED/SPILLED FROM
CUTTING(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:MATERIAL IN SOLID FORM DOES NOT REQUIRE SPECIAL
PRECAUTIONS IN HANDLING AND STORAGE. HOWEVER, USE INDUSTRIAL
HYGIENE AIR MONITORING TO ENSURE THAT USE OF THIS MATERIAL DOES NOT
CREATE EXPOSURES WHICH EXCEED LEVELS SPECIFIED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF SOLID METAL ALLOYS ARE CONVERTED IN MFG
(INCLUDING GRINDING, HIGH TEMP CUTTING & WELDING)PROCESSES TO
DUSTS, FUMES, GASES/MISTS & VENT IS NOT ADEQ TO MAINTAIN EXPOS
BELOW LIMITS SPECIFIED, THEN NIO SH/MSHA APPRVD RESP SHOULD BE
(SUPDAT)
Ventilation:IF SOLID METAL ALLOYS ARE CONVERTED TO DUST, FUMES/MISTS,
MAINTAIN WORKING ENVIRON BELOW EXPOS LIM SPECIFIED BY (SUPDAT)
FACE PROT & FLAME RETARDENT CLTHG. SELECT WELDING LENSE SHADES FROM
(ING 2)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PROD:OXIDES OF LISTED METALS, CHROMATES, FLUORIDES & COMPLEX
METALLICS. GASES MAY INCLUDE CO, OZONE & NOX. SPILL PROC:FROM
CUTTING, GRINDING/WELDING OPERATIONS, VACUUM RESIDUE INTO SUITABLE
CONTRS. RESP PROT:USED I/A/W OSHA 29CFR1910.134. VENT:USE OF ADEQ
EXHAUST VENT.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:5342F,2950C
Melt/Freeze Pt:M.P/F.P Text:2660F,1460C
Spec Gravity:8.9 (H2O = 1)
Solubility in Water:0
Appearance and Odor:GREY METALLIC WITH NO ODOR. SHAPED AS WIRE,
ROD/STRIP.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID ACIDS. CONTACT WITH MINERAL ACIDS WILL RELEASE HYDROGEN - A
READILY COMBUSTIBLE GAS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FUMES & GASES FROM WELDING & HIGH TEMP
CUTTING CONTAIN CONSTITUENTS DIFFERENT FROM INGRED LISTED & MAY
INCLUDE: (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IF IN ACCORDANCE WITH EPA OR LOCAL
REGULATIONS. DISPOSAL MUST BE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DYE,SOLVENT RED 24
CAGE:60777
CAGE:60777
============= Composition/Information on Ingredients =============
Ingred Name:DYE,SOLVENT RED 24,CAS#85-33-0
===================== Hazards Identification =====================
Effects of Overexposure:MFR STATES:NONE KNOWN,NOT ON ANY HAZ.LIST.
======================= First Aid Measures =======================
First Aid:REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEED. SKIN:WASH WITH
SOAP & WATER. EYES:FLUSH WITH WATER 15 MIN. KEEP WARM AND QUIET.
ING:GIVE MILK/WTR&INDUCE VOMIT-FOR ANY CONDITION SEEK MEDICAL ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WTR,DRY CHEM,CO*2
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:TOX.COMB.PRODUCTS,SUCH AS NITROUS OX.MAY
BE PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH APPVD DUST RESP.USING AN ABSORBENT
TO PREVENT DUSTING,SWEEP OR SHOVEL SPILLS INTO A WASTE DISPOSAL
CONTAINER.WASH DOWN THE AREA WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPVD DUST RESP.
Ventilation:LOCAL EXHAUST PREFERRED,MECHANICAL EXHAUST ACEPTABLE.
Other Protective Equipment:FULL PROTECTIVE CLOTHING,SAFETY SHOWER,EYE
WASH STATION
Supplemental Safety and Health
MSDS DATED 04-23-87/
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK BROWN POWDER,NO ODOR.
Percent Volatiles by Volume:0.34
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE SPECIFIED
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED INCINERATOR OR DISPOSE OF
IN APPROVED CHEMICAL DUMP IN ACCORDANCE WITH LOCAL,STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MOPAR MOTOR OIL ADDITIVE, 10W30, 04318087
Preparer's Name:SD PERROTT
CAGE:18113
CAGE:18113
CAGE:86403
============= Composition/Information on Ingredients =============
Ingred Name:POLYISOBUTENEYL-SUCCINIMIDE AND AMIDE
CAS:84605-20-9
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHOSPHORODITHOIC ACID, O-O-D1 C1-14-ALKYL ESTERS, ZINC
SALTS (2:1) (ZDDP)
CAS:68649-42-3
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL,HYDROTREATED (SEVERE), PETROLEUM DISTILLATE,
HEAVY PARAFFINIC
CAS:64742-54-7
RTECS #:PY8035501
Fraction by Wt: 10-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DDEWAXED
(SEVERE), HEAVY PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038501
Fraction by Wt: 10-30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)
LIGHT NAPHTHENIC
CAS:64742-53-6
RTECS #:PY8036001
Fraction by Wt: 10-30%
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:MINERAL OIL,HYDROTREATED (SEVERE), HEAVY NAPHTHENIC
DISTILLATE
CAS:64742-52-5
RTECS #:PY8035001
Fraction by Wt: 10-30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-REFINED
(SEVERE) LIGHT PARAFFINIC; (PETROLEUM OIL)
CAS:64741-89-5
RTECS #:PY8041501
Fraction by Wt: 10-30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT REFINED
(SEVERE), LIGHT NAPHTHENIC, (NON-CARCINOGENIC - IARC)
CAS:64741-97-5
RTECS #:PY8041001
Fraction by Wt: 10-30%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:MAY BE HARMFUL IF
INHALED. SKIN:IF CONFINED TO SKIN, MAY PRODUCE MINOR IRRITATION.
MAY BE ABSORBED THRU SKIN. PROLONGED SKIN EXPOSURE MAY RESULT IN
ALLERGIC SKIN REACTION. EYE:DIRECTCONTACT WILL PRODUCE MINOR
IRRITATION. INGESTION:NO KNOWN EFFECTS, HOWEVER, INGESTION IS NOT
RECOMMENDED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR AT ONCE. ARTF RESP IF BRTHG HAS
STOPPED. CARDIAC RESUSCITATION IF INDICATED. IF PULM SYMP DEVELOP,
CONSULT PHYS. SKIN:WASH W/SOAP & WATER. APPLY SKIN CREAM IF
DEFATTING OF SK IN OCCURS. EYE:RINSE IMMED W/LG AMTS OFWATER,
OCCASNLY LIFTING BOTH UPPER & LOWER LIDS. CONTINUE FOR @ LEAST 15
MINS. CONT PHYS. INGEST:DO NOT INDUCE VOMIT-CALL PHYS IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:372F,189C
Extinguishing Media:FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:EXPOSURE TO INTENSE HEAT AND DIRECT FLAME
MAY RSLT IN PRESS BUILD-UP IN CNTNR CAUSING WEAKENING/RUPTURING OF
CONTAINER.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNIT SOURCES (FLAMES, HOT SURF
& ELEC, STATIC OR FRICTIONAL SPARKS). CONTAIN W/DIKE. ABSORB ON
SUITABLE MEDIUM, PROVIDE ADEQUATE VENTILATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID USING/STORING @ HIGH TEMP. KEEP
AWAY FROM OPEN FLAME. STORE SEPARATE FROM INCOMPATABLE MATLS.
REACTS W/OXIDIZERS.
Other Precautions:AVOID BRTHG MIST. AVOID BRTHG VAP. AVOID SKIN CONT.
AVOID EYE CONT. AVOID INGEST. REMOVE CONTAMD CLTHG & LAUNDER BEFORE
REUSE. MAINTAIN GOOD HOUSEKEEPING AND HYGIENIC PRACTICES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL PROTECTION NEEDED UNDER NORMAL
CONDITIONS. NIOSH/MSHA ORGANIC VAPOR RESPIRATOR IF TLV OF PRODUCT
OR ANY COMPONENT IS EXCEEDED.
Ventilation:LOCAL EXHAUST VENTILATION.
Other Protective Equipment:EYE WASH. PVNT PRLNGD SKIN CONT W/CONTAMD
CLOTHING. WASH CONTAMD CLTHG BEFORE REUSE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:0.900
Solubility in Water:NEGLIGIBLE (<0.1%)
Appearance and Odor:AMBER LIQUID WITH MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURE, SPARKS OR OPEN FLAME.
Hazardous Decomposition Products:SMOKE, CARBON MONOXIDE, CARBON
DIOXIDE, ALDEHYDES, AND OTHER PROD OF INCOMPLETE COMBUSTION, INCLDG
HYDROGEN SULFIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN MANNER CONSISTENT WITH STATE,
PROVINCIAL, LOCAL, AND FEDERAL DISPOSAL REGULATIONS. FOR FURTHER
INFO CALL CORPORATE PURCHASING AT TIE LINE 859-7969 (OUTSIDE OF
CHRYSLER CALL 313/855-7969) .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PREMIUM VELVET VINYL LATEX FLAT-LTB
Preparer's Name:DOD/HMIS (DGSC-SSH)
CAGE:GO531
CAGE:0CUY5
CAGE:GO531
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 15.42%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 1.82%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CHROMATES
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: PULMONARY EDEMA MAY
DEVELOPE WITH INHALATION OF HIGH CONCENTRATIONS. THIS MATERIAL MAY
CAUSE NOSE AND THROAT IRRITATION. EYES: THIS PRODUCT CAN BE
IRRITATING TO THE EYES. SKIN: MAY CAUSE S KIN IRRITATION AND
DRYING/DEFATTING OR CRACKING AND DERMATITIS ON REPEATED OR
PROLONGED EXPOSURE TO THE SKIN.
Explanation of Carcinogenicity:MANUFACTURER STATE THIS PRODUCT CONTAINS
NO REPORTED CARCINOGENS OR SUSPECTED CARCINOGENS.
Effects of Overexposure:EYE, SKIN AND LUNG IRRITATION. CONTINUED
BREATHING OF VAPORS MAY IRRITATE RESPIRATORY TRACT CAUSING
HEADACHE, NAUSEA AND DIZZINESS. THIS PRODUCT MAY BE FATAL FROM
SWALLOWING LARGE AMOUNTS. MAY CAUSE N AUSEA, VOMITING, HEADACHES,
DIZZINESS, STUPOR, AND KIDNEY DAMAGE. INHALING THE CONTENTS MAY BE
HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN,
RESPIRATORY TRACT OR KIDNEY MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESUSCITATE IF NOT
BREATHING. CONTACT A PHYSICIAN IMMEDIATELY. EYES: IMMEDIATELY FLUSH
WITH LUKE WARM WATER FOR 15 MINUTES. GET MEDICAL ATTENTION. SKIN:
REMOVE CONTAMI NATED CLOTHING. WASH WITH SOAP AND WATER. CONTACT A
PHYSICIAN IMMEDIATELY. INGESTION: DO NOT INDUCE VOMITING. RINSE
MOUTH IMMEDIATELY. GIVE 6 TO 8 OUNCES OF WATER IF CONSCIOUS. GET
PHYSICIAN IMMEDIATE
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:241F,116C
Lower Limits:3.2
Upper Limits:15.3
Extinguishing Media:CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE
USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILDUP AND
POSSIBLE AUTOIGNITION. USE FOG NOZZLES WITH WATER.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:STAY UPWIND AND AWAY FROM SPILL UNLESS WEARING
APPROPRIATE PROTECTIVE EQUIPMENT. STOP AND/OR CONTAIN DISCHARGE IF
IT MAY BE DONE SAFELY. KEEP ALL SOURCES OF IGNITION AWAY. VENTILATE
AREA OF SPILL. USENON-SPARKING TOOLS FOR CLEANUP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PRODUCT CONTAINERS COOL, DRY AND
AWAY FROM SOURCES OF IGNITION. USE AND STORE WITH ADEQUATE
VENTILATION. DO NOT SMOKE IN STORAGE AREA.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTIED. NOTICE: REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED
OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND
NERVOUS SYSTEM DAMAGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATORS TO REMOVE
SOLID AIRBORNE PARTICLES OF OVER SPRAY DURING SPRAY APPLICATIONS.
IN RESTRICTED VENTILATION AREAS USE NIOSH/MSHA APPROVED RESPIRATOR
DESIGNED TO REMOVE BO TH PARTICLES AND VAPOR.
Ventilation:SUFFICIENT VENTILATION IN VOLUME AND PATTERN SHOULD BE
PROVIDED TO KEEP AIR CONTAMINATION BELOW OSHA'S CURRENT PELS.
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT BY USING AN
APRON.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM FACILITIES. DO NOT WEAR CONTAMINATED CLOTHING OR FOOTWEAR.
Supplemental Safety and Health
THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICAL SUBJECT TO THE
REPORTING REQUIREMENTS OF SECTION 313 OF THE EMERGENCY PLANNING AND
COMMUNITY RIGHT-TO-KNOW ACT OF 1986 AND OF 40 CFR 372. ETHYLENE GL
YCOL, CAS NUMBER 107-21-1, % BY WEIGHT=1.82%. **THIS MSDS COPIED
FROM ONE OF A SIMILAR PRODUCT FROM THE SAME MFR.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:379F,193C
Vapor Pres:10 @68F
Appearance and Odor:LIQUID
Percent Volatiles by Volume:47
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES, INCLUDING
CARBON DIOXIDE, CARBON MONOXIDE AND OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. DO NOT INCINERATE
CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PROPYLENE GLYCOL INDUSTRIAL
CAGE:0LWP6
CAGE:4N760
CAGE:0LWP6
============= Composition/Information on Ingredients =============
Ingred Name:1,2-PROPANEDIOL,CAS#57-55-6
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 99%.
===================== Hazards Identification =====================
Effects of Overexposure:MINOR EYE IRRITATION
======================= First Aid Measures =======================
First Aid:FLUSH EYES WITH WTR FOR 20-30MIN.SEE DOCTOR IF IRRITATION
PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point:211F,99C,TCC
Lower Limits:2.
Upper Limits:13.
Extinguishing Media:CO*2, FOAM, DRY CHEM & H*2O FOG.
Fire Fighting Procedures:USE WTR FOG FOR COOLNG.AVOID FROTHNG/STM
EXPLOS-SEE SUPPL.-
Unusual Fire/Explosion Hazard:FLASHBACK ALONG VAPOR TRAIL MAY OCCUR;
VAP MAY EXPL. IF IGNITED IN AN ENCLOSED AREA.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT TOUCH SPILLED MATL. ELIMINATE SOURCES.
EXCLUDE UNPROTECTED PERSONS FROM AREA. SM SPILL:ABSORB W
SAND,EARTH,OTHER ABSORB MATL,THEN FLUSH W H*20. LG SPILL: STOP
LEAK,DIKE FOR LATER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLSD CONT.STORE AWAY
FROM HEAT/MOISTURE/STRG.OXID.AGTS.DO NOT HEAT ABOVE 160F UNLESS IN
CLSD SYS.AWAY FROM AIR.
Other Precautions:HANDLE EMPTY CONT.W.CARE.RESIDUE CAN BURN IF
HEATED.EQUIPM.CONTAINING THIS MATERIAL SHOULD BE ISOLATED &
THOROUGHLY DRAINED,WASHED & PURGED PRIOR TO MAINTENANCE/REPAIR
OPERATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQMNTS UNDER ORDINARY
CONDITIONS/ADEQUATE VENT.
Ventilation:LOCAL EXHAUST TO ELIMINATE MISTS/FUMES/GASES.
Other Protective Equipment:FULL FACE SHLD;FULL PROT. CLTHG/BOOTS;
COVERALLS; PROT.APRON
Supplemental Safety and Health
MSDS DATED 10-28-86/SPEC.FIRE-FIGHTNG PROC:BURNING LIQ.MAY FLOAT ON
WTR.FIGHT FIRE FROM DIST/
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:365F,185C
Vapor Pres:0.1
Vapor Density:2.6
Spec Gravity:1.04
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS,SLIGHTLY VISCOUS,ALMOST ODORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPS. AND SEVERE OXIDIZING
CONDITIONS.
Hazardous Decomposition Products:INCOMPLETELY BURNED CARBON PRODUCTS,
CO*2, CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:128C546H01
CAGE:97942
CAGE:97942
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR,GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS PE RSON VOMIT.
===================== Fire Fighting Measures =====================
Flash Point:< 3 LB PCB
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMATIC ODOR.
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-056-3614
Product ID: JETWELD 1
Cage: 36232
=======================================================
Contractor Summary
=======================================================
Cage: 36232
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: ELECTRODE,WELDING
Specification Number: AWS E7024-1
Type/Grade/Class: UNKNOWN
Unit of Issue: LB
UI Container Qty: 0
Type of Container: UNKNOWN
=======================================================
Ingredients
=======================================================
Cas: 65996-67-0
% Wt: 35
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
% Wt: 10
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST; 9394
------------------------------
Cas: 1344-09-8
% Wt: 5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 7439-96-5
RTECS #: OO9275000
% Wt: <5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: C 5 MG/M3 DUST
ACGIH TLV: 5 MG/M3 DUST 9394
------------------------------
Cas: 65996-61-4
% Wt: <5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 14808-60-7
RTECS #: VV7330000
% Wt: <5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: SEE TABLE Z-3
ACGIH TLV: 0.1 MG/M3 RDUST;9394
------------------------------
Cas: 1332-58-7
RTECS #: GF1670500
% Wt: <5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 2 MG/M3 TDUST; 9394
------------------------------
Cas: 1344-28-1
RTECS #: BD1200000
% Wt: 1
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST; 9394
------------------------------
Cas: 1309-48-4
RTECS #: OM3850000
% Wt: 1
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 15 MG/M3 PARTICULATE
ACGIH TLV: 10 MG/M3;TDUST; 9394
------------------------------
Cas: 8049-17-0
RTECS #: LK1400000
% Wt: 1
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 1 MG FE/M3
ACGIH TLV: 1 MG FE/M3
------------------------------
Cas: 1314-13-2
RTECS #: ZH4810000
% Wt: <0.5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST; 9394
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: ORAL LD50 (RAT) IS UNKNOWN
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: INHALATION OF WELDING FUMES MAY CAUSE NERVOUS
SYSTEM AND MUSCLE IRREGULARITIES, IRRITATION OF EYES, NOSE, THROAT, AND
RESPIRATORY SYSTEM, METAL FUME FEVER. CHRONIC: INHALATION OF FUMES MAY CAUS E
SIDEROSIS AND AFFECT LUNG FUNCTION.
Explanation Of Carcinogenicity: NONE SPECIFIED BY MANUFACTURER.
Signs And Symptions Of Overexposure: INHALATION: NAUSEA, DIZZINESS, DRYNESS OF
NOSE AND THROAT, COUGHING, WHEEZING AND SHORTNESS OF BREATH. EYES: REDNESS,
TEARING, BLURRED VISION.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHALATION: REMOVE TO FRESH AIR. RESUSCITATE IF NEEDED. EYES: FLUSH
WITH PLENTY OF WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH WITH SOAP AND
WATER. INGESTION: DO NOT INDUCE VOMITING. SEE DOCTOR.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PICK UP RODS. SWEEP UP OR MOP. PLACE RESIDUE IN A
CONTAINER FOR DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: REMOVE ANY COMBUSTIBLES FROM WORK AREA:
SPARKS OR WELDING ARC COULD IGNITE NEARBY COMBUSTIBLES.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures: WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL
PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard: NON-FLAMMABLE; BUT SPARKS AND WELDING ARC MAY
IGNITE COMBUSTIBLES DURING USE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED RESPIRATOR FOR WELDING FUMES OR
SUPPLIED AIR RESPIRATOR IN CONFINED SPACES OR WHERE FUME CONCENTRATION
EXCEEDS REGULATORY LIMITS.
Ventilation: USE MECHANICAL OR LOCAL EXHAUST OR BOTH TO MAINTAIN LEVELS OF
FUMES BELOW REGULATORY LIMITS.
Other Protective Equipment: CLOTHING TO PROTECT ENTIRE BODY FROM SPARKS.
Work Hygienic Practices: WASH HANDS AFTER USE AND BEFORE EATING, DRINKING, OR
SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
B.P. Text: UNKNOWN
M.P/F.P Text: UNKNOWN
Decomp Text: UNKNOWN
Vapor Pres: UNKNOWN
Vapor Density: UNKNOWN
Spec Gravity: UNKNOWN
Evaporation Rate & Reference: UNKNOWN
Solubility in Water: NEGLIGIBLE
Appearance and Odor: OPAGUE, CHARCOAL COLORED SOLID
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: METAL FUMES
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 45031
Product ID: JETWELD 1
Review Date: 02/22/1993
Net Unit Weight: UNKNOWN
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: LB
Container QTY: 0
Type Of Container: UNKNOWN
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: JETWELD 1
Cage: 36232
Company Name: THE LINCOLN ELECTRIC CO
Street: 22801 ST CLAIR AVE
Zipcode: 44117-1199
Date Of Label Review: 02/22/1993
Status Code: C
Label Date: 02/22/1993
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RT-B/KRI3, 00927, RUST TOUGH RUST PREVENTIVE (SUPDAT)
CAGE:DO934
CAGE:DO934
CAGE:87187
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS) VP:
2
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 36%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 22%
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:VOLATILE ORGANIC COMPOUNDS - LESS WATER: 3.49 LBS/GAL
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HNDLG/STOR PREC:OFF STOVES, ELEC TOOLS & APPLIANCES & ANY
OTHER SOURCES OF IGNIT. CONSULT NFPA CODE. USE APPRVD (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:BONDING & GROUNDING PROC. KEEP CNTNR CLSD WHEN NOT IN
USE. TRANSFER ONLY TO APPRVD CNTNRS W/COMPLETE & (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:APPROP LABELING. DO NOT TAKE INTERNALLY. KEEP OUT OF
THE REACH OF CHILDREN.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:PRESENT AT HAZ LEVELS ONLY DURING
SANDING/ABRADING OF DRIED FILM. IF NO SPECIFIC DUSTS ARE LISTED,
(ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:THE APPLIC LIMITS FOR NUISANCE DUSTS ARE ACGIH TLV 10
MG/M3 (TOTAL DUST), OSHA PEL 15 MG/M3 (TOTAL DUST), (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERVOUS SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
POSS DEATH. HDCH, DIZZ, NAUS & LOSS OF COORDINATION ARE INDICATIONS
OF EXCESSIVE EXPOS TO VAP/S PRAY MISTS. REDNESS & ITCHING/BURNING
SENSATION MAY INDICATE EYE/ EXCESSIVE SKIN EXPOSURE. CHRONIC: (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:PRLNG OVEREXP TO SOLV INGRED IN PROD
MAY CAUSE ADVERSE EFTS TO LIVER & URINARY SYS. RATS EXPOS TO
TITANIUM DIOXIDE DUST AT 250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER,
SUCH EXPOS LEVELS ARE NOT ATTAINABLE IN THE WORKPLACE. RPTS HAVE
ASSOC RPTD & PRLNG OVEREXP TO SOLV W/PERM BRAIN & NERVOUS SYS DMG.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND
WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE.
EYES: FLUSH E YES WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION. INGESTION: SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:100F,38C
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFTIVE. IF WATER USED, FOG NOZZ PREF. WATER
MAY BE USED TO COOL CLSD CNTNRS TO (SUPDAT)
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELEC EQUIP, SPK & OPEN
FLAME. CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO EXTREME HEAT.
APPLICATN TO HOT SURF REQ SPECIAL PREC. DURING (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE COMBUST. KEEP AWAY FROM
HEAT, SPK & OPEN FLAME. VAP WILL ACCUM READILY & MAY IGNITE EXPLO.
DURING USE & UNTIL ALL VAP GONE:TURN (ING 4)
Other Precautions:INTENTIONAL MISUSE BY DELIB CONC & INHALING CONTENTS
CAN BE HARMFUL/FATAL. USE ONLY W/ADEQ VENT. AVOID BRTHG VAP & SPRAY
MIST. AVOID CNTCT W/SKIN & EYES. COATINGS MAY CNTN MATLS CLASSIFIED
AS NUISANCE PARTICULATES WHICH MAY BE (ING 7)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED < APPLIC
LIM BY VENT, WEAR PROPERLY FITTED ORG VAP/PARTICULATE RESP APPRVD
BY NIOSH/ MSHA. WHEN SANDING/ABRADING DRIED FILM, WEAR DUST/MIST
RESP APPRVD BY NIOSH/ MSHA FOR PROT AGAINST NON-VOLATILE MATLS
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS MAINTAINED <
APPLIC EXPOS LIM. REFER TO OSHA STD 1910.94, 107, 108.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:ENAMELS BULK-3. FIRE FIGHT PROC:PVNT PRESS
BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOS TO EXTREME HEAT. EXPLO
HAZ:EMER CNDTNS OVEREXP TO DECOMP PROD MAY CAUSE HLTH HAZ. SYMP MA
Y NOT BE IMMED APPARENT. OBTAIN MED ATTN.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:0.95-1.29
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE:CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
RCRA 40 CFR 261. WASTE MUST BE TESTED FOR IGNIT TO DETERM APPLIC
EPA HAZ WASTE NOS. INCIN IN APPRVD FACILITY. DO NOT INCIN CLSD
CNTNR. DISPOSE OF I/ A/ W FED, STATE & LOCAL REGS REGARDING
POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STYLE 153
Preparer's Name:DEREK COOMBER
CAGE:4R345
CAGE:4R345
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Fraction by Wt: 70-90%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9293
Ingred Name:STYRENE POLYMER WITH 1,3-BUTADIENE
CAS:9003-55-8
RTECS #:WL6478000
Fraction by Wt: 8-15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: >0.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: MATERIAL IN FINISHED FORM
PRESENTS NO KNOWN HEALTH HAZARD. CHRONIC: IF MATERIAL IS FURTHER
PROCESSED-ASBESTOSIS, LUNG CANCER, & MESOTHELIOMA, ALL OF WHICH ARE
DISABLING AND FATAL DISEASES OF T HE LUNG. INHALATION AND INGESTION
OF ASBESTOS FIBERS MAY CAUSE CANCER OF THE BOWEL.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS ASBESTOS
[12001-29-5], AN OSHA REGULATED CARCINOGEN.
Effects of Overexposure:INHALATION: FATIGUE AND SHORTNESS OF BREATH
THAT GETS WORSE WITH TIME AND EVENTUALLY BECOMES DISABLING. EYES:
IRRITATION. SKIN: IRRITATION. INGESTION: MILD STOMACH DISTRESS.
DIARRHEA, VOMITING, AND NA USEA.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND TUBERCULOSIS
ARE ALL GENERALLY AGGRAVATED BY EXPOSURE TO ASBESTOS FIBERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SEE DOCTOR. EYES: RINSE
THOROUGHLY WITH WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, SEE DOCTOR.
INGESTION: DIL UTE WITH WATER. DO NOT INDUCE VOMITING.SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NOT REQUIRED
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:THE RUBBER, ONCE IGNITED, MAY NEED EXTRA
COOLING TO PREVENT REIGNITION. COMBUSTION OR HEAT OF FIRE MAY
PRODUCE HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE-ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTAN T AND THEN SHOVEL OR MOP UP
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:ITEM IS NONFRIABLE & WILL NOT SHED
FIBERS IN NORMAL USE AND STORAGE. USED ITEMS SHALL BE WETTED
BEFORE, DURING & AFTER DISASSEMBLY.
Other Precautions:IF IT IS NECESSARY TO CUT OR IMPACT THE ITEM WHILE
INSTALLING IT, WEAR A RESPIRATOR AND PROTECTIVE CLOTHING. USED
ITEMS SHALL BE IDENTIFIED AND DISPOSED OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDE RAL REGULATIONS FOR ASBESTOS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO ENTRAIN ALL PARTICULATE
EMISSIONS. HEPA FILTER REQUIRED. NO LEAKS ON PRESSURE SIDE OF FAN.
Other Protective Equipment:NONE NORMALLY REQUIRED. USE COVERALLS OR
DISPOSABLE CLOTHING IF DUSTY CODITIONS OR FREE ASBESTOS OCCUR.
Work Hygienic Practices:WET WORK TO THE DEGREE POSSIBLE. WASH HANDS
AFTER HANDLING ITEM. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:DECOMPOSES
Spec Gravity:1.65-1.85
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK WITH WHITE SPOTS
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, AND STRONG ALKALIS
Stability Condition to Avoid:ACCUMULATIONS OF DUST
Hazardous Decomposition Products:BURNING RUBBER AND ASBESTOS DUST
==================== Disposal Considerations ====================
Waste Disposal Methods:WET THE MATERIAL WITH WATER AND SURFACTANT.
PLACE IN 6 MIL THICK POLYETHYLENE PLASTIC BAG. PLACE THESE BAGS
INTO ANOTHER POLY BAG OR A SAFE PLACE UNTIL IT CAN BE SHIPPED TO AN
APPROVED DISPOSAL SITE. IDENTIFY WITH ASBESTOS CANCER WARNING
LABEL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NATURAL GRAPHITE 1485
Preparer's Name:PETER ZALESKI
CAGE:06705
CAGE:06705
============= Composition/Information on Ingredients =============
Ingred Name:GRAPHITE
CAS:7782-42-5
RTECS #:MD9659600
OSHA PEL:15 MPPCF RDUST
ACGIH TLV:2 MG/M3 RDUST; 9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICA AS QUARTZ, MFR CAS
NO: 7631-86-9-1)
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: INHALATION IN EXCESS
MAY RESULT IN IRRITATION OF MUCOUS MEMBRANES.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE (QUARTZ): GROUP 2A
(IARC); ANTICIPATED TO BE A CARCINOGEN (NTP)
Effects of Overexposure:NOT KNOWN OTHER THAN THAT MENTIONED IN HEALTH
HAZARDS.
Medical Cond Aggravated by Exposure:IRRITATION TO EYES & SKIN.
BREATHING MAY BECOME DIFFICULT BY EXCESS DUST.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/PLENTY OF WATER FOR SEVERAL MINUTES. SEEK
MEDICAL HELP. SKIN:WASH W/SOAP & WATER. INGEST:DO NOT INDUCE
VOMITING. SEEK MEDICAL ATTENTION. INHAL:REMOVE TO FRESH AIR AREA.
SEEK MEDICAL ATTEN TION IF BREATHING BECOMES DIFFICULT.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:GRAPHITE CAUSES SLIPPERY CONDITIONS. CAREFULLY
SWEEP UP MATERIAL & WASH FLOOR W/SOAP & WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:GRAPHITE BEING CONDUCTIVE CAN CAUSE
SHORT CIRCUITS & OTHER ELECTRICAL MALFUNCTIONS. KEEP CONTAINER
TIGHTLY CLOSED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST & MECHANICAL (GENERAL) ARE NECESSARY.
Other Protective Equipment:EYEWASH STATION & PROTECTIVE CLOTHING.
Work Hygienic Practices:HANDLE CAREFULLY TO PREVENT ANY SPILLS.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.25 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK GRAY SOLID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE & CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE ACCORDING TO FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:22-106, PLASTIC KOTE LATEX SEMI GLOSS PAINT, (SUPDAT)
CAGE:75734
CAGE:75734
CAGE:55652
============= Composition/Information on Ingredients =============
Ingred Name:ING 14:LEVEL OF 250 MG/M3 IS APPROX 50 TIMES THAT PERMITTED
IN OCCUP ENVIRON.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:SYMPTOMATICALLY.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:IMPOUNDING. ASSURE CONFORMITY W/APPLIC GOVT
REGS. CONTINUE TO OBSERVE PRECS FOR VOLAT, COMBUST VAPS (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:FROM ABSORBED MATERIAL.
RTECS #:9999999ZZ
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL;(2,2,4-TRIMETHYL-1,3-PENTANEDIOL
MONOISOBUTYRATE)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 2-2.8%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALUMINUM SILICATE
CAS:1335-30-4
Fraction by Wt: 0-6.3%
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 0-1.65%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:ETHYLENE GLYCOL (SARA III). LD50:(ORAL,RAT) 8.5 G/KG.
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 1.8-2.8%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM, VAP/MIST, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SYNTHETIC RESIN; (SYNTHETIC RESIN COMPLEX). %: 23.7-26.7.
Fraction by Wt: SEE ING
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-19.3%
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 45-62.2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUNDS. %: 1.20 LBS/GAL.
RTECS #:9999999VO
Fraction by Wt: SEE ING
Ingred Name:SUPDAT:ASPIR OF MATL INTO LUNGS CAN CAUSE CHEM PNEUM WHICH
CAN BE FATAL. SLIGHTLY TOX TO HUMANS. CAUSES MENTAL (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:SLUGGISHNESS FOLLOWED BY DFCLTY IN BRTHG & HEART
FAILURE, KIDNEY & BRAIN DMG, POSS DEATH. PRACTICALLY NON-(ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:TOX TO ANIMALS. NOTICE:RPTS HAVE ASSOC RPTD & PRLNG
OCCUP OVEREXPS TO SOLVS W/PERM BRAIN & NERV SYS DMG. (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:INTENTIONAL MISUSE BY DELIB CONCENTRATING & INHALING
CONTENTS MAY BE HARMFUL/FATAL. ING 6:IN INHAL STUDY,(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:MFR'S TOXICOLOGY LAB FOUND EVID OF LUNG CANCER
(MALIGNANT TUMORS) IN 1 OUT OF 77 MALE RATS & 13 OUT OF 74(ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:FEMALE RATS AFTER THEY WERE EXPOS TO 250 MG/M3
TITANIUM DIOXIDE RESPIRABLE DUST FOR 2 YR PERIOD. EXPOS (ING 15)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 4.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:EXCESSIVE INHAL OF VAPS CAN
CAUSE NASAL & RESP IRRIT, DIZZ, WEAK, FATG, NAUS &/OR HDCH. OVEREXP
CAN CAUSE NEUROLOGICAL DMG. MISTS/VAPS FROM HOT OPERATIONS CAN
CAUSE MENTAL SLUGGISHNESS, PULM EDE MA (ACCUM OF FLUID IN LUNGS,
SIGNS & SYMPS CAN BE DELAYED FOR SEVERAL HRS) & BRONCH PNEUM.
INDIVIDUAL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:MAY EXPER DIZZ/LT HEAD WHEN WORKING IN
AREAS OF HIGH VAP CONCS. SKIN:DUE TO INDIVIDUAL SENSIT, THIS PROD
CAN CAUSE IRRIT UPON PRLNG/RPTD CONT. EYES:TRACE AMTS OF AMINE &
RESIDUAL MONOMER VAPS MAY BE IRRIT ESP IN POORLY VENTILATED AREAS.
IRRIT IN FORM OF REDNESS, TEARING &/OR BLURRED VISION. VAPS CAN
(SUPDAT)
Medical Cond Aggravated by Exposure:EFFECTS OF REPEATED OVEREXPOSURE.
NO EVIDENCE OF ADVERSE EFFECTS FROM AVAILABLE INFORMATION.
======================= First Aid Measures =======================
First Aid:INHAL:VICTIM SHOULD SEEK AIR FREE OF VAPS. IF BRTHG STOPS,
BEGIN ARTF RESP & SEEK IMMED MED ATTN. SKIN:THORO WASH EXPOS AREA
W/SOAP & LG QTYS OF WATER FOR AT LST 15 MINS. REMOVE CONTAM CLTHG
BEFORE RE USE. EYES:FLUSH W/LG QTYS OF WATER FOR AT LST 15 MINS,
LIFTING UPPER & LOWER LIDS OCCAS. INGEST:DRINK 1-2 GLASSES OF WATER
TO DILUTE. DO NOT INDUCE VOMIT. CONSULT MD/POIS CTL CTR IMMED.
TREAT (ING 16)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>212F,>100C
Extinguishing Media:CLASS B EXTINGUISHER. USE FOAM, CARBON DIOXIDE OR
DRY CHEMICAL FIRE FIGHTING APPARATUS.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
WATER MAY BE UNSUITABLE AS EXTING MEDIA, BUT HELPFUL IN KEEPING
ADJACENT CNTNRS COOL. AVOID (SUPP DATA)
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND/BE MOVED BY VENT & IGNITED BY HEAT, PILOT LIGHTS, OTHER
FLAME & IGNIT SOURCES AT LOCATIONS DIST FROM HNDLG (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL IGNIT SOURCES (FLARES, FLAMES INCL
PILOT LIGHTS, ELEC SPKS). RECOVER FREE PROD. ADD SAND, EARTH/OTHER
SUITABLE ABSORB TO SPILL AREA. MIN SKIN CONT. VENTILATE CONFINED
SPACES. KEEP PROD OUT OF SEWERS & WATERCOURSES BY DIKING OR (ING
17)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. KEEP OUT OF THE
REACH OF CHILDREN.
Other Precautions:DO NOT EAT, DRINK OR SMOKE WHILE HANDLING THIS
PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THE USE OF RESPIRATORY PROTECTION DEPENDS ON
VAPOR CONCENTRATION ABOVE TIME WEIGHTED TLV: USE NIOSH/MSHA
APPROVED RESPIRATOR.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL) &/OR LOCAL EXHAUST
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:THOROUGHLY WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:ACCENT BASE. FIRE FIGHT PROC:SPREADING BURNING
LIQ W/WATER USED FOR COOLING. EXPLO HAZ:POINT. NEVER USE
WELDING/CUTTING TORCH ON/NEAR CNTNR (EVEN EMPTY) BECAUSE VAPS MAY
IGNIT E. EFTS OF OVEREXP:CAUSE SEV CONJ. INGEST:CAN CAUSE GI IRRIT,
NAUS, VOMIT & DIARR. (ING 9)
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.13
pH:7.5
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INFINITELY
Appearance and Odor:VISCOUS LIQUID; MILD ODOR.
Percent Volatiles by Volume:72
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THIS PROD IS INCOMPATIBLE W/STRONG OXIDIZING AGENTS, STRONG ACIDS OR
BASES & SELECTED AMINES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION IN PRESENCE OF
AIR MAY YIELD CARBON MONOXIDE &/OR CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PRODUCT I/A/W APPLICABLE LOCAL,
COUNTY, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TRIETHYLBORANE (TEB)
CAGE:DO667
CAGE:98502
CAGE:97854
CAGE:DO667
============= Composition/Information on Ingredients =============
Ingred Name:TRIETHYLBORANE
CAS:97-94-9
RTECS #:ED2100000
Fraction by Wt: 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50: 235 MG/KG (MALE RATS)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: CHEMICAL & THERMAL BURNS.
INHALATION: SEVERE IRRITATION OF RESPIRATORY TRACT, DIFFICULT
BREATHING CONVULSIONS, & DEATH. IF A KNOWN EXPOSURE OCCURS, DON'T
WAIT FOR SYMPTOMS TO DEVELOP.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: CHEMICAL & THERMAL BURNS.
INHALATION: SEVERE IRRITATION OF RESPIRATORY TRACT, DIFFICULT
BREATHING, CONVULSTIONS & DEATH. IF A KNOWN EXPOSURE OCCURS, DON'T
WAIT FOR SYMPTOMS TO DEVELOP.
======================= First Aid Measures =======================
First Aid:INGESTION: GIVE SEVERAL GLASSES OF WATER, DON'T INDUCE
VOMITING. DON'T GIVE ANYTHING BY MOUTH TO UNCONSCIOUS/CONVULSING
PERSON. SKIN: REMOVE ALL CONTAMINATED CLOTHING/SHOES. FLUSH
AFFECTED AREAS W/RUN NING WATER FOR AT LEAST 15 MINS. GET MED ATT.
DISCARD CONTAMINATED CLOTHING. EYE: FLUSH W/RUNNING WATER FOR 15
MINS. INHALATION: REMOVE TO FRESH AIR. IF VICTIM IS BREATHING GIVE
OXYGEN. GET MED ATT.
===================== Fire Fighting Measures =====================
Flash Point:SPONTANEOUSLY
Extinguishing Media:DRY CHEMICAL, DRY SAND, VERMICULITE, CO2 OR WATER
Fire Fighting Procedures:A STANDARD ALUMINIZED FIREFIGHTING SUIT IS
RECOMMENDED FOR FIGHTING LARGE BORON ALKYL FIRES. IGNITES
SPONTANEOULY ON CONTACT W/AIR.
Unusual Fire/Explosion Hazard:DON'T USE FOAM, CARBON
TETRACHLORIDE/CHLOROBROMOMETHANE EXTINGUISHING AGENTS; REACTS
VIOLENTLY & LIBERATES TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:BLOCK OFF SOURCE OF SPILL. EXTINGUISH FIRE
W/EXTINGUISHING AGENT. REIGNITION MAY OCCUR. IF FIRE CAN'T BE
CONTROLLED W/EXTINGUISHING AGENT, KEEP A SAFE DISTANCE, PROTECT
ADJACENT PROPERTY & ALLOW PRODU CT TO BURN UNTIL CONSUMED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE UNDER AN INERT ATMOSPHERE.
CONTAINERS SHOULD BE STORED IN A COOL, DRY, WELL-VENTILATED AREA
AWAY FROM FLAMMABLE MATERIALS/SOURCES OF HEAT/FLAME.
Other Precautions:ALL FOOD MUST BE KEPT IN A SEPARATE AREA AWAY FROM
THE STORAGE/USE LOCATION. EXCERISE DUE CAUTION TO PREVENT DAMAGE TO
OR LEAKAGE FROM THE CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH-APPROVED POSITIVE-PRESSURE SCBA OR
AIR-SUPPLIED RESPIRATOR.
Ventilation:THIS MATERIAL MUST BE HANDLED IN AN OPEN OR WELL-VENTILATED
AREA.
Other Protective Equipment:EYE WASH, SAFETY SHOWER.
Work Hygienic Practices:UPON SKIN CONTACT DON'T ATTEMPT TO NEUTRALIZE
W/CHEMICL AGENTS. DISCARD CONTAMINATED CLOTHES, SHOES.
Supplemental Safety and Health
DON'T USE WELDING/CUTTING TORCH ON OR NEAR ANY CONTAINER OF THIS
MATERIAL, EVEN EMPTY, BECAUSE AN EXPLOSION COULD OCCUR.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:203F
Melt/Freeze Pt:M.P/F.P Text:-59.2F
Vapor Pres:13
Vapor Density:0.685
Appearance and Odor:CLEAR, COLORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS VIOLENTLY OR LIBERATES TOXIC FUMES ON CONTACT W/FOAM, CARBON
TETRACHLORIDE OR CHLOROBROMOMETHANE.
Stability Condition to Avoid:REACTS SLOWLY W/WATER. REACTS
VIOLENTLY/IGNITES SPONTANEOUSLY W/AIR. OXYGEN/ORGANIC HALIDE
COMPOUNDS REACT VIGOROUSLY.
Hazardous Decomposition Products:CO2, WATER & BORON OXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF EMPTY CONTAINERS ACCORDING TO
REGULATIONS UNDER RCRA. DISPOSE OF MATERIAL BY CONTROLLED
COMBUSTION/BY DILUTING TO <15% W/HEPTANE, TREAT W/HYDROGEN PEROXIDE
UNDER A NITROGEN ATMOSPHERE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RE4MFTH-55;BE SERIES REINHIBITOR FOR MIL-A-46153,PART 1
Kit Part:Y
Preparer's Name:J L OTTOWITZ
CAGE:NO599
CAGE:30255
CAGE:NO599
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 15-25%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:C 50 PPM,VAPOR; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:DIETHYLENE GLYCOL(AN IMPURITY CONTAINED IN ETHYLENE
GLYCOL(INGRED #1) AT 0-8%)
CAS:111-46-6
RTECS #:ID5950000
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 15-25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM HYDROXIDE (CERCLA)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:1,H-BENZOTRIAZOLE (4 OR 5)-METHYL SODIUM SALT
CAS:64665-57-2
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BENZOTRIAZOLE
CAS:95-14-7
RTECS #:DM1225000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: >1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 20-60%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:**CORROSIVE(ALKALINE)** EYES:MAY CAUSE
SEVERE IRRITATION OR BURNS.SKIN:MAY CAUSE SEVERE
IRRITATION,BURNS,POSSIBLE BLINDNESS.INGEST:MAY CAUSE GI TRACT
IRRITATION.INHAL:MAY CAUSE RESPIRATORY IRRITATION, PULMONARY
EDEMA,SYSTEMIC TOXICITY.CHRONIC:CNS EFFECTS(DIZZINESS,IRREGULAR EYE
MOVEMENT),SKIN SENSITIZATION,DERMATITIS.
Explanation of Carcinogenicity:ETHYLENE GLYCOL HAS BEEN SHOWN TO BE A
TERATOGEN IN MICE.
Effects of Overexposure:INHAL:PULMONARY EDEMA(HORSENESS,DIFFICULTY
BREATHING),NAUSEA,VOMITING,HEADACHE,DIZZINESS,IRREGULAR EYE
MOVEMENT.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING KIDNEY
DISEASE MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.CALL DOCTOR IF IRRITATION DEVELOPS.EYES:FLUSH WITH WATER FOR
15 MINUTES.CALL DOCTOR IF IRRITAITON PERSISTS.INHAL:REMOVE TO FRESH
AIR.GIVE OXY GEN OR ARTIFICIAL RESPIRATION IF NEEDED.INGEST:DO NOT
INDUCE VOMITING.GET PROMPT QUALIFIED MEDICAL ATTENTION.IF
CONSCIOUS,RINSE MOUTH;GIVE MILK OR WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:LARGE FIRES:ALCOHOL FOAM.SMALL FIRES:WATER
FOG,CARBON DIOXIDE,DRY CHEMICAL.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:AVOID USING A DIRECT STREAM OF WATER ON
BURNING PRODUCT;MAY CAUSE FROTHING.FIRE CONDITIONS MAY EVOLVE TOXIC
FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER RESPIRATORY AND PROTECTIVE
EQUIPMENT.VENTILATE AREA.DILUTE SPILLED LIQUID WITH AN EQUAL AMOUNT
OF WATER;SOAK UP WITH A NON-COMBUSTIBLE INERT
ABSORBANT(CLAY,SAND);PLACE IN PROPER CONTAINER F OR DISPOSAL.
Neutralizing Agent:NOT REPORTED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.KEEP AWAY FROM
INCOMPATIBLE MATERIALS.
Other Precautions:EMPTY CONTAINERS MAY CONTAIN HAZARDOUS
RESIDUE;DISPOSE OF PROPERLY.DO NOT MIX WITH OTHER CHEMICALS.AVOID
BREATHING VAPORS/MISTS.AVOID SKIN AND EYE CONTACT.KEEP OUT OF REACH
OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE EITHER A SELF-CONTAINED BREATHING APPARATUS OR
A NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC VAPORS,DEPENDING ON
THE AIRBORN CONCENTRA TION.
Ventilation:LOCAL VENTILATION AT THE WORKSITE;MECHANICAL(GENERAL)
VENTILATION TO MAINTAIN TLV/PEL.
Other Protective Equipment:PROTECTIVE CLOTHING,AS NEEDED.PROVIDE A
LOCAL EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
KEY1;C2.REFER TO NSN-6850-01-397-4960.NOTE TO DOCTOR:EMESIS SHOULD BE
WEIGHED AGAINST POSSIBLE CORROSION TO THE ESOPHAGUS;NEUTRALIZATION
IS NOT RECOMMENDED.THE PRINCIPAL TOXIC AGENT IS ETHYLENE GLYCOL
;ETHANOL IS ANTIDOTAL(INITIAL LOAD 100MG/DL;FOLLOW W/ MAINTAINANCE
DOSE AND POSSIBLE HEMODIALYSIS).
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:=107.8C, 226.F
B.P. Text:226F,108C
Melt/Freeze Pt:=-28.9C, -20.F
M.P/F.P Text:-20F,-29C
Spec Gravity:1.261-1.357
pH:14
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID;ORANGE-YELLOW.ODOR NOT REPORTED.
Corrosion Rate:CORROSIV
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS,STRONG OXIDIZERS,MATERIALS REACTIVE WITH HYDROXYL
COMPOUNDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.RCRA CODE IS D002(CORROSIVE).
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:140 0431 5L EKTAPRINT 2 DEL REPL LORR-M
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:BENZYL ALCOHOL
CAS:100-51-6
RTECS #:DN3150000
Fraction by Wt: 30-35%
Ingred Name:WATER, H2O
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 30-35%
Ingred Name:GLYCOL ETHERS, DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 25-30%
Ingred Name:TRIETHANOLAMINE
INTENDED CHANGE (IC)
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: 5-10%
Other REC Limits:A2 CARCINOGEN
ACGIH TLV:3.1 MG/CUM IC
Ingred Name:STILBENE BRIGHTENER
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYE: IRRITATION. INHALATION: LOW
HAZARD FOR USUAL INDUSTRIAL HANDLING.
Explanation of Carcinogenicity:TRIETHANOLAMINE IS CONSIDERED AN A2
CARCINOGEN.
Effects of Overexposure:SKIN/EYE: IRRITATION. INHALATION: LOW HAZARD
FOR USUAL INDUSTRIAL HANDLING.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH THOROUGHLY W/SOAP & WATER. GET MEDICAL ATTENTION IF REQUIRED.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2, ALCOHOL FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH MATERIAL TO SEWER W/LARGE AMOUNTS OF
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:THIS CHEMICAL IS A STRONG ACIDIC
AQUEOUS SOLUTION/MAY CAUSE ADVERSE ENVIRONMENTAL EFFECTS. AVOID
CONTACT W/EYES, SKIN, & CLOTHING.
Other Precautions:THE DIRECT INSTANTANEOUS DISCHARGE TO A RECEIVING
BODY OF WATER FOR AN AMOUNT OF THIS CHEMICAL FORMULATION WHICH WILL
RAPIDLY PRODUCE, BY DILUTION, A FINAL CONC. OF 0.1 MG/ OR LESS
ISN'T EXPECTED TO C AUSE AN ADVERSE ENVIRONMENTAL IMPACT.
============= Exposure Controls/Personal Protection =============
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT
Supplemental Safety and Health
AFTER DILUTION W/A LARGE AMOUNT OF WATER, FOLLOWED BY SECONDARY WASTE
TREATMENT, THE CHEMICALS IN THIS FORMULATION AREN'T EXPECTED TO
HAVE ANY ADVERSE ENVIRONMENTAL IMPACT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:16
Vapor Density:1.47
Spec Gravity:1.071
pH:10
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR AMBER SOLUTION; SWEET ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:FIRE OR HEAT
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE, OR LOCAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENAM ALKYD LUSTERLESS LO VOC CN WHITE 37875
Preparer's Name:W.A. ELLISON, OPRTNS MGR
CAGE:PRATT
CAGE:PRATT
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ISOAMYL KETONE
CAS:110-12-3
RTECS #:MP3850000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT NAPTHA LIGHT AROMATIC
CAS:64742-95-6
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9192
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MINERAL SPIRITS (VAPOR PRESSURE 2 MMHG @ 20C)
CAS:64475-85-0
RTECS #:PY8240000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/525 MG/CU.M.
ACGIH TLV:100 PPM/525 MG/CU.M.
Ingred Name:VOC. 3.09 LB/GAL LESS WATER & NEGLIGIBLY PHOTCHEMICALLY
REACTIVE MATERIALS 371 G/L LESS WATER CALCULATED.
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC. 5.48 LB/GAL SOLIDS 658 G/L SOLIDS CALUCATED
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CRYSTALLINE SILICA-PNEUMOCONIOSIS, A
PROGESSIVELY DISABLING LUNG DISEASE. XYLENE MAY CAUSE INJURY TO
LIVER, KIDNEYS & BLOOD. REPORTS ASSOCIATE PROLONGED/REPEATED
OVEREXPOSURE TO SOLVENT W/PERMANENT BR AIN & NERVOUS SYSTEM DAMAGE.
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING CONTENT
MAY BE HARMFUL OR FATAL
Explanation of Carcinogenicity:CRYSTALLINE SILICA HAS LIMITED EVIDENCE
OF CARCINOGENICITY IN HUMANS & SUFFICIENT EVIDENCE IN EXPERIMENTAL
ANIMALS.
Effects of Overexposure:SWALLOW:GASTROINT09JAN91
IRRIT,NAUSEA,VOMIT.ASPIRATION INTO LUNGS, POSSIBLE CHEM
PNEUMONITIS, CAN BE FATAL. INHALED:NOSE OR THROAT IRRIT, HIGH
CONCENTRATE MAY CAUSE ACUTE CENTRAL NERV SYST DEPRESS,HEA
DACHES,DIZZ,NAUSEA & CONFUSION. EYES:IRRIT. SKIN:LIQ MATERIAL MAY
BE ABSORBED THRU SKIN IN HARMFUL AMTS. DEFATT & IRRIT.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY CONDITIONS
MAY BE AGGRAVATED BY EXPOSURES TO CRYSTALLINE SILICA.
======================= First Aid Measures =======================
First Aid:SWALLOW:DON'T INDUCE VOMIT. CALL PCC/HOSPITAL/PHYSICIAN.
INHALED:REMOVE TO FRESH AIR IMMED. IF BREATHE STOPPED, GIVE CPR.
KEEP WARM/QUIET. GET MED ATTN. EYES:FLUSH W/LG AMTS OF H2O LIFTING
LIDS FOR AT LEAST 15 MINS. GET MED ATTN. SKIN:REMOVE CONTAM
CLOTHES. WASH AFFECTED AREA W/SOAP & WATER. OBTAIN MED ATTN IF
IRRIT PERSIST. NOTE TO PHYSICIAN:DIRECT TREATMENT AT CONTROL OF
SYMPTOMS & CLINICAL COND
===================== Fire Fighting Measures =====================
Flash Point:24 F/-4 C
Extinguishing Media:USE NFPA CLASS B FIRE EXTINGUISHERS DESIGNED FOR
FLAMMABLE LIQUID FIRES. POLYMER FOAM IS PREFERRED FOR LARGE FIRES.
Fire Fighting Procedures:USE WATER TO COOL EXPOSED CONTAINERS TO
PREVENT PRESSURE BUILD-UP/AUTO-IGNITE/EXPLOSION FROM EXTREME HEAT.
IF WATER USED, FOG NOZZLES ARE PREFERRABLE.
Unusual Fire/Explosion Hazard:OVEREXPOSURE TO DECOMPOSITION PRODUCTS
MAY CAUSE HEALTH HAZARD. SYMPTOMS MAY NOT BE IMMEDIATLY APPARENT.
OBTAIN MEDICAL ATTENTION. WARNING! FLAMMABLE!
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. ELIM IGNITE SOURCES.
DIKE & CONTAIN W/INERT MATERIAL(SAND)TRANSFER LIQ TO COVERED METAL
CONTAINER FOR RECOVERY/DISPOSAL. REMOVE W/INERT ABSORB. USE ONLY
NON-SPARK TOOLS. PREVENT CONTAM OF SEWERS,GROUNDWATERS
W/MATERIAL/ABSORB
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 95 F. STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29CFR1910.106. CLOSE CONTAINER
AFTER EACH USE.
Other Precautions:DON'T TAKE INTERNALLY. KEEP AWAY FROM CHILDREN. DON'T
BREATHE SANDING DUST. EMPTY CONTAINERS MUST NOT BE WASHED & RE-USED
AT ALL. GROUND & BOND CONTAINERS TO RECEIVING CONTAINERS. NEVER USE
PRESSURE T O EMPTY. DRUM IS NOT A PRESSURE VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WELL VENTED AREA MAY NOT REQUIRE USE OF RSPRTR.
RESTRICTED VENTILATION:CHEM CARTRIDGE RSPRTR MAY BE REQUIRED.
SPRAY:USE MECH PREFILTER. CONFINED AREA:USE AIR SUPPLIED RSPRTR. IF
OVER TLV USE PROPERLY FITTED RSPRTR WITH PROTECTION FACTOR
Ventilation:GEN DILUTION/LOCAL EXHAUST VENT IN SUFFICIENT VOL/PATTERN
TO KEEP CONCENTRATE OF HAZARD INGRED BELOW LOWEST LIMITS.
Other Protective Equipment:EYEWASH FACILITY, SAFETY SHOWER.
Supplemental Safety and Health
THIS PRODUCT, IF DISCARDED DIRECTLY, WOULD BE CLASSIFIED A HAZARDOUS
WASTE BASED ON ITS IGNITABILITY CHARA09JAN91IC, I.E. HAS A FLASH
POINT OF 140 DEG. F. OR LESS. THE PROPER RCRA CLASSIFICATION WOULD
BE D001.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:139 TO 348F
Vapor Density:> THAN AIR
Evaporation Rate & Reference:SLOWER THAN ETHER.
Percent Volatiles by Volume:43
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE AND CARBON
DIOXIDE.
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT, SPARKS AND
FLAME.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE &
LOCAL LAWS. INCINERATE ONLY EPA PERMITTED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. OBSERVE PRECAUTIONS FOR DISPOSAL OF
FLAMMABLE MATERIALS. CONTAMINAT ED ABSORB MAY BE DISPOSED IN HAZARD
WASTE LANDFILL
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ZINIC IZ-260-MS RACK
Preparer's Name:KEITH FREY
CAGE:0A7F7
CAGE:0A7F7
============= Composition/Information on Ingredients =============
Ingred Name:ZINC OXIDE *94-3*
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 4%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM FUME
Ingred Name:NICKEL SULFATE (HUMAN CARCINOGEN BY IARC, SUSPECTED ANIMAL
CARCINOGEN BY IARC) *94-3*
CAS:7786-81-4
RTECS #:QR9350000
Fraction by Wt: 1.38%
OSHA PEL:0.1 MG/CUM
ACGIH TLV:0.1 MG/CUM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SODIUM HYDROXIDE, CAUSTIC SODA, LYE
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 12%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/CUM
ACGIH TLV:0.2 MG/CUM CEILING
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT):240MG/KG SODIUM HYDROXIDE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION/DAMAGE TO UPPER
RESPIRATORY TRACT/LUNG TISSUE, MAY PRODUCE CHEMICAL PNEUMONIA.
SKIN: TISSUE DESTRUCTION ON CONTACT/SEVERE BURNS/PRIMARY
IRRITANT/DERMATITIS. EYES: TISSUE DESTRUC TION ON CONTACT/SEVERE
BURNS/BLINDNESS.INGESTION: SEVERE BURNS/COMPLETE TISSUE PERFORATION
OF MUCOUS MEMBRANES (SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, BURNS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS.
SKIN: IMMEDIATELY WASH W/PLENTY OF WATER FOR 15 MINS. INHALATION:
REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED. INGESTION: NEVER
GIVE AN YTHING BY MOUTH TO AN UNCONSCIOUS PERSON. DON'T INDUCE
VOMITING. GIVE LARGE QUANTITIES OF WATER/SEVERAL GLASSES OF MILK.
KEEP AIRWAY CLEAR IF VOMITING OCCURS SPONTANEOUSLY. (SEE SUPP)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CO2
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:WILL REACT W/ALUMINUM, TIN & ZINC TO
RELEASE FLAMMABLE HYDROGEN GAS. CONTACT W/NITRO COMPOUNDS MAY FORM
SHOCK SENSITIVE SALTS.
================== Accidental Release Measures ==================
Spill Release Procedures:SOILED POWDERS MAY BE SHOVELED UP & STORED IN
CLOSED CONTAINERS FOR POSSIBLE NORMAL USE/PROPER DISPOSAL.
CONTAIN/ABSORB LIQUIDS W/SUITABLE ABSORBENT/FLUSH TO WASTE
TREATMENT AREA. FLUSH AREA W/PLENTY OF WATER. NEUTRALIZE FINAL
TRACES AFTERFLUSHING.
Neutralizing Agent:DILUTE MINERAL ACID
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA IN A TIGHTLY
CLOSED CONTAINER WHEN NOT BEING USED.
Other Precautions:AVOID CONTACT W/SKIN & EYES. CONTAINERS WILL RETAIN
PRODUCT RESIDUE/VAPORS EVEN WHEN EMPTY. DON'T USE CONTAINERS FOR
ANY OTHER PURPOSE. ALWAYS OBEY HAZARD WARNINGS & HANDLE EMPTY
CONTAINERS AS IF THEY WERE FULL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WHERE
MIST/SPRAY/DUST MAY BE GENERATED ABOVE TLV LIMIT.
Ventilation:ADEQUATE LOCAL EXHAUST WHERE DUST/MIST/SPRAY MAY BE
GENERATED TO MAINTAIN LEVEL BELOW TLV LIMIT.
Other Protective Equipment:CHEMICALLY RESISTANT SHOES & APRON, SAFETY
SHOWERS, EYE WASH FACILITY.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. DISCARD CLOTHING THAT CAN'T BE DECONTAMINATED. WASH AFTER
HANDLING.
Supplemental Safety and Health
HEALTH HAZARDS CONT'D: OF MOUTH, THROAT, ESOPHAGUS & STOMACH. FIRST AID
CONT'D: OBTAIN MEDICAL ATTENTION IN ALL CASES. TO PREPARE
SOLUTIONS: THIS MATERIAL DISSOLVES W/THE LIBERATION OF MUCH HEAT.
ADD MATERIAL SLOWLY W/CONSTANT STIRRING TO AVOID VIOLENT
SPLATTERING.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text: 212F
Spec Gravity:1.2
Evaporation Rate & Reference:(WATER =1): >1
Solubility in Water:COMPLETE
Appearance and Odor:BLUISH-VIOLET COLORED LIQUID
Percent Volatiles by Volume:78
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, FLAMMABLE LIQUIDS, ALUMINUM, TIN, ZINC, MAGNESIUM,
ORGANIC HALOGENATED & NITRO COMPOUNDS
Hazardous Decomposition Products:REACTS W/SOME METALS TO FORM FLAMMABLE
HYDROGEN GAS. CONTACT W/NITRO COMPOUNDS MAY FORM SHOCK SENSITIVE
SALTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T DISCHARGE CAUSTIC WASTE SOLUTION INTO
SEWERS/STREAMS. NEUTRALIZE TO A LOCALLY ACCEPTABLE PH & THEN WELL
DILUTE W/WATER. MAY ALSO REQUIRE PRECIPITATION & FILTRATION OF
HEAVY METALS. DISPOSE OF IA W/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DUAL SHIELD WIRES 85-CL
CAGE:GO230
CAGE:GO230
CAGE:84021
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL (SOLUBLE) (SUSPECTED HUMAN CARCINOGEN BY NTP, IARC,
ACGIH) INTENDED CHANGE (IC)
CAS:7440-02-0
RTECS #:QR5950000
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:10 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:MANGANESE, MN COMPOUNDS
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:CALCIUM FLUORIDE, FLUORSPAR, CALCIUM DIFLUORIDE, IRTRAN 3,
LIPARITE
CAS:7789-75-5
RTECS #:EW1760000
Other REC Limits:2.5 MG/CUM (AS F)
OSHA PEL:2.5 MG/CUM (AS F)
ACGIH TLV:2.5 MG/CUM (AS F)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF NOSE, THROAT, EYES. MAY
LEAD TO SIDEROSIS WHICH MAY AFFECT PULMONARY FUNCTION. ARC RAYS CAN
INJURE EYES & BURN SKIN. ELECTRIC SHOCK CAN KILL. SEE SUPP.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:INHALATION: DIZZINESS, NAUSEA, IRRITATION OF
NOSE & THROAT. EYES: IRRITATION. SKIN: DRYNESS & BURNS.
Medical Cond Aggravated by Exposure:RESPIRATORY OR ALLERGIC CONDITIONS.
======================= First Aid Measures =======================
First Aid:EMPLOY FIRST AID TECHNIQUES RECOMMENDED BY THE AMERICAN RED
CROSS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS CAN IGNITE
COMBUSTIBLES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP HEAD OUT OF FUMES, DON'T TOUCH
LIVE ELECTRICAL PARTS, INSULATE FROM WORK & GROUND.
Other Precautions:TO DETERMINE COMPOSITION & QUANTITY OF FUMES & GASES
TO WHICH WORKERS ARE EXPOSED IS TO TAKE AN AIR SAMPLE INSIDE THE
WELDERS HELMET OR IN THE WORKER'S BREATHING ZONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATORY WHEN WELDING IN CONFINED SPACE OR WHERE LOCAL EXHAUST
OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:LOCAL EXHAUST AT THE ARC TO KEEP THE FUMES & GASES BELOW
THE TLV.
Other Protective Equipment:HELMET, ARM PROTECTORS, APRONS, HATS,
Supplemental Safety and Health
THE PRODUCT AS SUPPLIED IS NON-HAZARDOUS. HEALTH HAZARDS OCCUR DURING
OPERATIONS. THE COMPOSTION & QUANTITY OF WELDING FUMES ARE
DEPENDENT ON THE PROCESS, PROCEDURES, MEDIA, CONTAMINENTS IN THE
ATMOSP HERE, & ELECTRODES USED.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SEE SUPP
Stability Condition to Avoid:SEE SUPP
Hazardous Decomposition Products:CO, CO2, OZONE & NITROGEN OXIDES
FORMED BY THE RADIATION FROM ARC. WELDING FUMES - COMPLEX OXIDES
FROM THE INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
W/FEDERAL, STATE & LOC AL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CG AGENT SIMULANT VIAL
Kit Part:Y
CAGE:60737
CAGE:60737
============= Composition/Information on Ingredients =============
Ingred Name:PHENYLCHLOROFORMATE
CAS:1885-14-9
RTECS #:FG3850000
Other REC Limits:NOT KNOWN
OSHA PEL:NOT KNOWN
ACGIH TLV:NOT KNOWN
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 RAT ORAL 1410 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED,INHALED OR
ABSORBED THROUGH SKIN.CAUSES BURNS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN/INGESTION:CAUSES BURNS.
INHALATION:VAPOR IS IRRITATING.
Medical Cond Aggravated by Exposure:NOT KNOWN
======================= First Aid Measures =======================
First Aid:EYES/SKIN:FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. INGESTION:DO NOT INDUCE VOMITING. INHALATION:REMOVE TO
FRESH AIR.GIVE ARTIFICIAL RESPIRATION,IF NECESSARY.REMOVE
CONTAMINATED CLOTH ING.
===================== Fire Fighting Measures =====================
Flash Point:168F,76C
Lower Limits:NOT KNOWN
Upper Limits:NOT KNOWN
Extinguishing Media:USE CARBON DIOXIDE,FOAM,OR DRY CHEMICAL.DO NOT USE
WATER.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS (SCBA)
AND FULL TURNOUT GEAR .PREVENT EYE AND SKIN CONTACT.USE WATER TO
COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES OF HYDROGEN CHLORIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA.REMOVE SOURCES OF IGNITION.WEAR
CLOSED CONTAINER FOR DISPOSAL.
Neutralizing Agent:NOT KNOWN
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT,SPARK OR
FLAME.AVOID CONTACT WITH ACIDS AND WATER.
Other Precautions:DO NOT BREATHE VAPORS.DO NOT GET ON SKIN,IN EYES,OR
ON CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR OSHA/MSHA ORGANIC RESPIRATOR OR SCBA.
Ventilation:CHEMICAL FUME HOOD.
Other Protective Equipment:NOT KNOWN
Work Hygienic Practices:NOT KNOWN
Supplemental Safety and Health
BOILING POINT: 167F,75C AT 13 MMHG.
================== Physical/Chemical Properties ==================
HCC:F6
Boiling Pt:B.P. Text:SEE SUPP
Melt/Freeze Pt:M.P/F.P Text:NOT KNOWN
Decomp Temp:Decomp Text:NOT KNOWN
Vapor Pres:NOT KNOWN
Vapor Density:>1 (AIR=1)
Spec Gravity:1.248 (WATER=1)
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:NOT KNOWN
Appearance and Odor:LIQUID
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS,WATER.
Stability Condition to Avoid:MOISTURE
Hazardous Decomposition Products:HYDROGEN CHLORIDE GAS,CARBON MONOXIDE
AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP MUST BE IAW FED,STATE,& LOC REGS.COORDINATE
W/ SUPPORTING INSTALLATION/MACOM ENVIRON OFFICE PRIOR TO DISP
.DISSOLVE OR MIX WITH COMBUSTIBLE SOLVENT AND BURN IN AN
INCINERATOR WITH AN AFTERB URNER AND SCRUBBER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INK CARTRIDGE M6904 G/A (CYAN), F47-0401-500
CAGE:08YZ7
CAGE:08YZ7
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 75-85%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TRIETHYLENE GLYCOL
CAS:112-27-6
RTECS #:YE4550000
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER-SOLUBLE SOLVENT; (WATER-SOLUBLE ORGANIC SOLVENT)
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ISOPROPYL ALCOHOL (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 1-2%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500STEL
Ingred Name:COPPER COMPOUNDS
Fraction by Wt: 2.5%
OSHA PEL:1 MG CU/M3
ACGIH TLV:1 MG CU/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50(ORAL,RAT):>2000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:MAY BE SLIGHTLY HARMFUL.
INGESTION:MAY BE HARMFUL IF SWALLOWED. EYE CONTACT:MAY CAUSE SLIGHT
IRRITATION. SKIN CONTACT:MAY CAUSE SLIGHT IRRITATION. CHRONIC:NO
DATA AVAILABLE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION:IF PERSON BREATHES IN LARGE AMOUNTS, MOVE THE
EXPOSED PERSON TO FRESH AIR. GET MEDICAL ATTENTION.
INGESTION:OBTAIN MEDICAL ATTENTION IMMEDIATELY. EYE:FLUSH WITH
PLENTY OF WATER FOR AT LEAST 15 MINUTES. SKIN:WASH WITH WATER AND
SOAP.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:WATER, CO*2, DRY CHEMICALS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE OFF WITH PAPER OR WET CLOTH.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NOT REQUIRED.
Ventilation:NOT REQUIRED.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.03 (H*20=1)
pH:4 TO 9
Solubility in Water:MISCIBLE
Appearance and Odor:CYAN LIQUID WITH A MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MAY BE SUBJECT TO FEDERAL, STATE OR
LOCAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NAPHTHA STCC 4910259
CAGE:63415
CAGE:63415
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA
Fraction by Wt: >99%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OR INGESTION MAY
CAUSE CENTRAL NERVOUS SYTEM (CNS) DEPRESSION. CONTACT MAY IRRITATE
SKIN AND EYES.INHALATION MAY CAUSE RESPIRATORY IRRITATION.
SWALLOWING MAY CAUSE DIGESTIVE SYSTEM I RRITATION. CHRONIC:
PROLONGED OR REPEATED EXPOSURE MAY CAUSE CANCER, CNS DAMAGE,
DERMATITIS.
Explanation of Carcinogenicity:BENZENE IS LISTED AS A KNOWN CARCINOGEN
BY IARC AND NTP.
Effects of Overexposure:INHALED/INGESTED: COUGHING, SHORTNESS OF
BREATH, DIZZINESS, STUPOR, HEADACHE, NAUSEA, VOMITING, DIARRHEA.
EYES: REDNESS, TEARING, BLURRED VISION, PAIN. SKIN: REDNESS, RASH,
PAIN, BLISTERING.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN AND
RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALED: MOVE TO FRESH AIR. GIVE ARTIFICIAL RESPERATION IF
BREATHING STOPPED. GIVE OXYGEN IF BREATHING DIFFICULT. GET MEDICAL
ATTENTION. EYES: FLUSH WITH LOTS OF WATER FOR 15 MINUTES. SEE
DOCTOR. SKIN : REMOVE CONTAMINATED CLOTHES. WASH WITH SOAP AND
WATER. INGESTED: DO NOT INDUCE VOMITING! IF CONSCIOUS, GIVE WATER.
GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>-40F,>-40C
Autoignition Temp:Autoignition Temp Text:>450F
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM, OR WATER SPRAY
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
BUNKER GEAR. MOVE CONTAINERS IF NO RISK. COOL FIRE EXPOSED
CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:VAPOR FORM EXPLOSIVE MIXTURE WITH AIR.
LIQUID FLOATS ON WATER; DO NOT USE DIRECT STREAMS OF WATER TO
EXTINGUISH.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. CONTAIN
SPILL. STOP LEAK IF POSSIBLE/NO RISK. ABSORB WITH INERT MATERIAL
AND PLACE IN A CLEAN, LABELED CONTAINER FOR LATER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
PLACE AWAY FROM SOURCES OF IGNITION AND STRONG OXIDIZING AGENTS.
Other Precautions:USE PROPER BONDING AND GROUNDING PROCEDURES DURING
TRANSFER OPERATIONS. DO NOT BREATH VAPORS OR MISTS. DO NOT GET IN
EYES, ON CLOTHES OR SKIN. DO NOT SMOKE IN AREA OF USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE OR
EMERGENCY OPERATIONS OCCUR; USE NIOSH/MSHA APPROVED RESPIRATOR OR
SUPPLIED AIR RESPIRATOR, OR SCBA, AS REQUIRED. USE IN ACCORDANCE
WITH 29 CFR 1910.134.
Ventilation:USE LOCAL EXHAUST VENTILATION TO MAINTAIN AIRBORNE
CONCENTRATIONS BELOW PEL.
Other Protective Equipment:IMPERVIOUS CLOTHES, BOOTS TO PREVENT
PROLONGED OR REPEATED SKIN CONTACT. EYE WASH STATION.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:>86F,>30C
Melt/Freeze Pt:M.P/F.P Text:-70F,-57C
Vapor Pres:40 MM HG
Vapor Density:3.4(AIR=1)
Spec Gravity:0.74 (WATER=1)
Evaporation Rate & Reference:10 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID WITH ODOR LIKE GASOLINE OR
KEROSENE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:SOURCES OF IGNITION. CONTACT WITH
INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:OXIDES OF CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A CCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CALIBRATION CHECK GAS, 804770
CAGE:8F723
CAGE:8F723
============= Composition/Information on Ingredients =============
Ingred Name:CARBON MONOXIDE. SOL IN H*2O: 3.5 CM3/100ML (0C)
CAS:630-08-0
RTECS #:FG3500000
Fraction by Wt: 0.0050%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM
Ingred Name:METHANE. SOL IN H*2O: 9 CM3/100ML (20C)
CAS:74-82-8
RTECS #:PA1490000
Fraction by Wt: 1.45%
OSHA PEL:N/K
ACGIH TLV:ASPHYXIANT
Ingred Name:OXYGEN. SOL IN H*2O: 3.2 CM3/100ML (25C)
CAS:7782-44-7
RTECS #:RS2060000
Fraction by Wt: 15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HYDROGEN SULFIDE (SARA 302/313) (CERCLA) SOL IN H*2O: 437
CM3/100ML (0C)
CAS:7783-06-4
RTECS #:MX1225000
Fraction by Wt: 0.0010%
OSHA PEL:20 PPM, C
ACGIH TLV:10 PPM/15 STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:NITROGEN. SOL IN H*2O: 2.3 CM3/100ML (0C)
CAS:7727-37-9
RTECS #:QW9700000
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:ASPHYXIANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: METHANE IS A SIMPLE ASPHYXIANT
(ACGIH 1992-93). EXPOSURE TO 500-1000 PPM CARBON MONOXIDE MAY CAUSE
HEADACHE, RAPID BREATHING, NAUSEA, WEAKNESS, DIZZINESS AND
CONFUSION. HYDROGEN SULFIDE IS AN I RRITANT OF THE EYES AND
RESPIRATORY TRACT. TARGET ORGANS: CARBON MONOXIDE: LUNGS, BLOOD,
TISSUES. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CARBON MONOXIDE AT TOXIC
CONCENTRATIONS CAUSES TISSUE HYPOXIA (LACK OF OXYGEN) BY PREVENTING
BLOOD FROM TRANSPORTING SUFFICIENT OXYGEN. HYDROGEN SULFIDE IS AN
IRRITANT OF THE EYES AND RESPIR ATORY TRACT.
Medical Cond Aggravated by Exposure:CARBON MONOXIDE BURDEN MAY
AGGRAVATE ANAGINA PECTORIS. PREGNANT WOMEN ARE REPORTEDLY MORE
SENSITIVE THAN OTHERS. EFFECTS OF CO EXPOSURE ARE AGGRAVATED BY
HEAVY LABOR, HEAT STRESS AND HIGH ALTITUDE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. ADMINISTER OXYGEN. CONSULT
MD IMMEDIATELY. EYES: FLUSH WITH POTABLE WATER FOR AT LEAST 15
MINUTES. SEE MD . SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. SEE MD
(F P N). INGESTION: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:THIS GAS MIXTURE IS NOT FLAMMABLE. USE MEDIA
SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:GAS UNDER PRESSURE, 500 PSIG AT 70F. DO
NOT EXCEED 120F.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. AVOID BREATHING GAS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
AREA. DO NOT EXCEED 120F.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUE TO LIMITED AMOUNT OF GAS IN CYLINDER, & LOW
RELEASE RATE EMPLOYED IN INSTRUMENT CALIBRATION, RESPIRATORY
PROTECTION IS NOT INDICATED UNDER CONDITIONS OF INTENDED USE. USE
NIOSH/MSHA APPROVED RESP APPROPRIATE FOR EXPOS OF CONCERN .
Ventilation:MECHANICAL VENTILATION IS SUITABLE.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:AVOID BREATHING GAS. USE IN WELL-VENTILATED
AREAS. FOLLOW THE CALIBRATION PROCEDURE DETAILED IN THE MSA (SUP
DAT)
Supplemental Safety and Health
HYGIENE PRACT: INSTRUCTION MANUAL PROVIDED WITH THE INSTRUMENT UNDER
CALIBRATION.
================== Physical/Chemical Properties ==================
Vapor Pres:500 PSIG
Vapor Density:APPROX 1
Solubility in Water:SEE INGREDIENTS
Appearance and Odor:COLORLESS, MALODOROUS GAS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT PUNCTURE OR INCINERATE CYLINDER. BEFORE
DISCARDING CYLINDER, SLOWLY RELEASE CONTENT TO A SAFE EXHAUST.
DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3101, ACRI VIN BLACK
Preparer's Name:J. G. PRINZ
CAGE:45281
CAGE:45281
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III). VP: 0.1 @ 68F.
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 3%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name: (SILICA)
CAS:68855-54-9
Fraction by Wt: 3.95%
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:(ACUTE) MAY CAUSE IRRIT TO SKIN, EYES,
& INTESTINAL SYS. (CHRONIC) NONE KNOWN. ADVERSE HLTH EFTS FROM
VAPS/SPRAY MISTS IN POORLY VENT AREAS MAY INCL IRRIT OF MUC MEMB OF
NOSE, THROAT, & RESP TRACT & S YMP OF HDCH & NAUS. EYES: INDIRECT
CONTMAY CAUSE IRRIT. SKIN: PRLNGD/RPTD CONT W/PROD MAY CAUSE SKIN
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: IRRITATION. SKIN ABSORP: REDNESS,
DRYING OF SKIN, OR OTHER SIGNS OF IRRITATION OR CONTACT DERMATITIS.
INGESTION: CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING,
AND DIARRHEA.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMED WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. TAKE TO PHYSICIAN FOR MEDICAL ATTENTION. SKIN: CLEANSE
THOROUGHLY WITH SOAP AND WATER. REMOVE ALL CONTAMINATED CLOTHING.
INGESTIO N: DRINK 1-8 GLASSES OF WATER TO DILUTE. DO NOT INDUCE
VOMITING. CONSULT PHYSICIAN OR POISON CONTROL CENTER IMMED. TREAT
SYMPTOMATICALLY. INHALATION: REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Lower Limits:3.2%
Upper Limits:15.3%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:THIS IS WATER-BASED PRODUCT. WILL NOT SUPPORT
COMBUSTION. WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO HIGH
TEMPERATURES MAY BURST DUE TO BUILD UP OF STEAM PRESSURE.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE, CONTAIN, OR ABSORB WITH INERT MATERIAL
(I.E., SAND, VERMICULITE, ETC.) TRANSFER TO CONTAINERS FOR RECOVERY
OR DISPOSAL. PREVENT RUNOFF INTO SEWERS, STREAMS, OR OTHER BODIES
OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT EXPOSE TO EXTREMES IN
TEMPERATURES. AVOID EXPOSURE TO HIGH TEMPERATURES. DO NOT ALLOW TO
FREEZE.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PROLOGNED OR REPEATED
EXPOSURE TO LEVELS ABOVE TLV.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. IF TLV IS EXCEEDED, USE
NIOSH/MSHA APPROVED ORGANIC VAPOR AND MIST PROTECTION.
Ventilation:USE ADEQUATE MECHANICAL (GENERAL &/OR LOCAL) VENTILATION TO
MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING. FURNISH EYEWASH
STATIONS.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING RESTROOMS.
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:ING 1
Vapor Density:LTR/AIR
Spec Gravity:1.4 (H2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:DILUTABLE
Appearance and Odor:TYPICAL FOR WATER-BASED LATEX COATINGS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND ALKALIS AND MATERIALS THAT REACT WITH WATER.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: ISOPROPYL-BETA-D-THIOGALACTOPYRANOSIDE, 102101
Cage: 1H1H0
=======================================================
Contractor Summary
=======================================================
Cage: 1H1H0
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Cas: 367-93-1
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: THE MATERIAL IS A CARCINOGEN. TARGETS LIVER,
KIDNEYS AND THE CENTRAL NERVOUS SYSTEM. MAY INCLUDE MODERATE TO SEVERE
ERYTHEMA (REDNESS) AND MODERATE EDEMA (RAISED SKIN). ADDITIONAL INSTRUCTIONS:
OBSERVE PROPER LABORATORY PROCEDURES WHEN HANDLING MATERIAL.
Explanation Of Carcinogenicity: SEE HEALTH HAZARDS.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
First Aid: SKIN: REMOVE CONTAMINATED CLOTHING AND RINSE WITH COPIOUS AMOUNTS OF
SOAP AND WATER FOR A CONSIDERABLE AMOUNT OF TIME. CALL PHYSICIAN. INGESTION:
DRINK 1-2 GLASSES OF WATER WITHIN 15 MINUTES. ALWAYS C ALL PHYSICIAN OR TAKE
PATIENT TO HOSPITAL. EYE: RINSE LIBERALLY WITH WATER FOR AT LEAST 15 MINUTES.
ALWAYS CALL PHYSICIAN OR TAKE TO HOSPITAL. INHALATION: TAKE PATIENT INTO
FRESH AIR AND ALLOW TO REST . ALWAYS CALL PHYSICIAN OR TAKE PATIENT TO
HOSPITAL.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SWEEP INTO SUITABLE CONTAINER FOR DISPOSAL.
Waste Disposal Methods: MATERIAL MAY BE DISPOSED OF IN TRASH. MATERIAL MAY BE
FLUSHED DOWN DRAIN. DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL REGULATIONS (FP N).
Handling And Storage Precautions: STORAGE TEMPERATURE: -0C. NO SPECIAL
PRECAUTIONS NECESSARY. FOLLOW PROPER LABORATORY PROCEDURES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: CO*2, DRY CHEMICAL, OR FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: NO UNUSUAL HAZARD. DECOMP OF SUBSTANCE WHEN
HEATED OR BURNED: TOXIC FUMES OF SO*X.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN (FP N).
Other Protective Equipment: EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N).
Supplemental Safety and Health: GENERAL PROPERTIES: CHEMICAL FORMULA: C9H18SO5.
MFR QUALITY CONTROL FAX #330-562-2642.
=======================================================
Physical/Chemical Properties
=======================================================
Melt/Freeze Pt: =122.C, 251.6F
Solubility in Water: SOLUBLE
Appearance and Odor: WHITE OR OFF WHITE POWDER.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: TOXIC FUMES OF SO*X.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
Transport Information: UN# NOT AVAILABLE.
=======================================================
Regulatory Information
=======================================================
Federal Regulatory Information: W #NC.
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: ISOPROPYL-BETA-D-THIOGALACTOPYRANOSIDE, 102101
Cage: 1H1H0
Company Name: ICN BIOCHEMICALS
Street: 1263 S CHILLICOTHE ROAD
Zipcode: 44202
Label Required IND: Y
Date Of Label Review: 12/07/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE/CHRONIC: THE MATERIAL IS A CARCINOGEN. TARGETS
LIVER, KIDNEYS AND THE CENTRAL NERVOUS SYSTEM. MAY INCLUDE MODERATE TO SEVERE
ERYTHEMA (REDNESS) AND MODERATE EDEMA (RAISED SKIN). ADDITIONAL INSTR
UCTIONS: OBSERVE PROPER LABORATORY PROCEDURES WHEN HANDLING MATERIAL.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3010370 A-1177-B-1
Kit Part:Y
Preparer's Name:CLIFFORD PEARSON
CAGE:25472
CAGE:25472
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN SYSTEM
Fraction by Wt: <75%
Ingred Name:CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: <25%
OSHA PEL:5 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:SILICA, AMORPHOUS FUMED (IARC, GROUP 3) *95-1*
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <5%
OSHA PEL:0.1 MG/CUM
ACGIH TLV:0.1 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MINOR TRANSIENT IRRITATION.
SKIN: MINOR IRRITATION, ALLERGIC REACTION, SENSITIZATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: MINOR TRANSIENT IRRITATION. SKIN: MINOR
IRRITATION, ALLERGIC REACTION, SENSITIZATION.
Medical Cond Aggravated by Exposure:SKIN RASHES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. INHALATION:
REMOVE TO FRESH AIR. INGESTION: INDUCE VOMITING. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:DON'T ENTER CONFINED FIRE SPACE W/OUT PROPER
PROTECTIVE EQUIPMENT & NIOSH APPROVED SELF CONTAINED BREATHING
APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID EYE & SKIN CONTACT. ABSORB W/INERT
ABSORBANT, SCRAPE UP & PLACE IN A CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY PLACE AWAY FROM
HEAT.
Other Precautions:AVOID EYE & SKIN CONTACT. KEEP OUT OF REACH OF
CHILDREN. EMPTY CONTAINERS MAY BE HAZARDOUS & ALL PRECAUTIONS CITED
SHOULD BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE USUALLY NECESSARY UNDER MOST INDUSTRIAL
OPERATING CONDITIONS.
Ventilation:GOOD GENERAL VENTILATION USUALLY ADEQUATE.
Other Protective Equipment:CLEAN LONG SLEEVES & LEG CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V7
Vapor Density:>1
Spec Gravity:1.37
Evaporation Rate & Reference:(N-BU AC = 1): 1
Appearance and Odor:VERY VISCOUS LIQUID W/AN EPOXY ODOR.
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACID, BASE, AMINE COMPOUNDS IN UNCONTROLLED CONDITIONS.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:CO, CO2, TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.