text
stringlengths 307
13.1k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
* Exposure Controls/Personal Protection *
Respiratory Protection:TYPICAL USAGE OF PRODUCT DOES NOT REQUIRE THE
USE OF A RESPIRATOR. HOWEVER, IN AN EMERGENCY SITUATION, USE A
NIOSH/MSHA APPROVED ORGANIC VAPOR OR AIR-LINE RESPIRATOR. USE A
NIOSH/MSHA APPROVED SCBA IN CONFINED SPACES.
Ventilation:LOCAL EXHAUST RECOMMENDED TO KEEP AIR CONCENTRATION WELL
BELOW ESTABLISHED TLV.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: EMOLLIENT RICH CREAM. INGEST: DO NOT INDUCE VOMITING.
KEEP PERSON WARM, QUIET, AND GET MEDICAL ATTENTION. ASPIRATION OF
MATERIAL INTO THE LUNGS DUE TO VOMITING CAN CAUSE CHEMICAL PNEUM
ONITIS WHICH CAN BE FATAL.
* Product Identification *
Kit Part:Y
Preparer's Name:RICHARD STOLLEY
* Composition/Information on Ingredients *
Ingred Name:PROPANE, 2,2-BIS (P-(2,3-EPOXY PROPOXY)PHENYL)-;
Ingred Name:DGBA EPOXY RESINS; (BISPHENOL A EPOXY RESIN)
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC
PETROLEUM DIST.)
Ingred Name:2-PENTANONE, 4-METHYL-; (METHYL ISOBUTYL KETONE) (SARA
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY CAUSE SEV SKIN INJURY
(REDDENING & SWELLING). MAY CAUSE CHEM BURNS IN EYE W/IRREVERSIBLE
DAM. MAY CAUSE RESP IRRIT. SWALLOWING CAN CAUSE NAUS, DIARR,
CRAMPING & WEAKNESS. CHRONIC:PRLNGD CONT W/SKIN MAY CAUSE SENSIT &
ALLERGENIC RESPONSES. PRLNGD BRTHG OF VAPS CAN LEAD TO SAME EFTS AS
INGEST. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CHRONIC OVEREXPOSURE MAY LEAD TO
KIDNEY AND LIVER DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR. IF BRTHG HAS STOPPED, ARTF RESP SHLD
BE STARTED. O*2 MAY BE ADMIN. IF READILY AVAILABLE SEEK MED ATTN
OCCASIO NALLY. GET MED ATTN IF IRRIT PERSISTS. TREATMENT IS MOST
EFTIVE W/IN 1 MIN. SKIN:THORO WASH EXPOSED AREA W/SOAP & WATER.
REMOVE CONTAMD CLTHG. LAUNDER CONTAMD CLTHG BEFORE REUSE. APPLY
(SUPP DATA)
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. USE ABSORBANT
SUCH AS PAPER, VERMICULITE, ETC TO CONTAIN SPILL. DO NOT FLUSH TO
SEWER. PLACE INTO LABELED CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:MIXTURE OF PART A & B WILL HARDEN AND
GENERATE HEAT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:F4
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR; PETROLEUM DIST. ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS AND OTHER EPOXY RESINS; STRONG OXIDIZERS.
Stability Condition to Avoid:MIXTURE OF PART A AND PART B WILL HARDEN
AND GENERATE HEAT.
Hazardous Decomposition Products:ACRID SMOKE, CARBON MONOXIDE AND
OXIDES OF NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:DESTROY BE LIQUID INCINERATION. CONTAMINATED
ABSORBANT MAY BE DISPOSED OF IN A LANDFILL I/A/W FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED CANISTER FOR ORGANIC VAPORS
(I.E. TYPE GMA FROM MINE SAFETY APPLIANCE CO).
Ventilation:MECHANICAL (GENERAL).
Other Protective Equipment:CLEAN, BODY-COVERING CLOTHING. BOOTS, AND
APRON, DEPENDING UPON EXPOS LIKELY, OR AS REQD BY COMPANY. EYE
(SUPDAT)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PROT EQUIP:FOUNTAIN & SAFETY SHOWER IN WORK AREA.
* Product Identification *
Product ID:MACOL 2
* Composition/Information on Ingredients *
(POLYOXYPROPYLENE GLYCOL)
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: TRACE
ACGIH TLV:1 PPM, A2
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INGEST/SKIN/EYE/INHLATION:NO
EVIDENCE OF ADVERSE EFFECTS FROM AVAILABLE INFORMATION. EFFECTS OF
OVEREXPOSURE:CONTACT WITH SKIN OR EYES NOT EXPECTED TO CAUSE
IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:KNOWLEDGE OF AVAIL TOXICOLOGY INFO
AND OF PHYSICAL & CHEM PROPERTIES OF MATL SUGGESTS THAT
OVEREXPOSURE IS UNLIKELY TO AGGRAVATE EXISTING MEDICAL CONDITIONS.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
CONTACTED SKIN AREAS W/SOAP & WATER. IF IRRITATION DEVELOPS, CONSUL
PHYS . SOAKED CLOTHING SHOULD BE CHANGED IMMEDIATELY!
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:CARBON DIOXIDE OR DRY CHEM ON SMALL FIRES. USE FOAM
(ALCOHOL, POLYMER/ORDINARY) AND WATER SPRAY FOR LARGE FIRES.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
* Accidental Release Measures *
Spill Release Procedures:(USE APPROP SFTY EQUIP). USE ABSORBENT
MATERIAL TO COLLECT & CONTAIN FOR DISPOSAL. CONTAIN LARGE SPILLS &
PUMP INTO SUITABLE TANK. WASH AREA W/SUITABLE DETERGENT &
THOROUGHLY RINSE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN WELL VENTILATED AREAS AT
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:NOT KNOWN
Appearance and Odor:CLEAR LIQUID, POLYOL ODOR
Percent Volatiles by Volume:<1
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIAL CAN CAUSE A REACTION.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON MONO/DIOXIDES.
* Disposal Considerations *
Waste Disposal Methods:ALL LOCAL, STATE AND FEDERAL REGULATIONS
CONCERNING HEALTH AND POLLUTION SHOULD BE REVIEWED TO DETERMINE
APPROVED DISPOSAL PROCEDURES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED SUPPLIED AIR RESPIRATOR
(SELF-CONTAINED OR AIR-LINE) IN HIGH VAPOR CONCENTRATIONS.
Ventilation:THIS PROD SHOULD BE CONFINED W/IN CLSD EQUIP, IN WHICH
CASE, GEN (MECH) ROOM VENT SHOULD BE SATISFACTORY. (ING 7)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:J MARKS
* Composition/Information on Ingredients *
Ingred Name:ETHYL ALCOHOL (ETHANOL)
Ingred Name:NYLON MULTIPOLYMER RESIN; (NYLON TERPOLYMER)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: <3%
Fraction by Wt: 1.5%
Ingred Name:SUPDAT: USE OF LOCAL EXHAUST EQUIPMENT IS RECOMMENDED TO
CONTROL EMMISSIONS NEAR THE SOURCE.
Ingred Name:VENT: SPECIAL, LOCAL VENT IS NEEDED @ POINTS WHERE VAPORS
ARE EXPECTED TO ESCAPE TO THE WORKPLACE AIR.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: HIGH VAPOR
CONCENTRATIONS MAY CAUSE BURNING SENSATION IN THE NOSE & THROAT.
DIZZINESS, NAUSEA, DROWSINESS & VOMITING MAY ALSO OCCUR. SKIN CONT:
PROLONGED OR REPEATED SKIN CONTACT CAN CAU SE DRYING & BRITTLENESS.
EYE CONT: MAY CAUSE IRRITATION. THERE MAY BE MILD TO MODERATE
CONJUNCTIVITIS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: INGEST: MAY CAUSE DIZZINESS,
EUPHORIA, NAUSEA, VOMITING AND LOCK OF COORDINATION. LONG TERM
REPEATED ORAL EXPOSURE TO ETHANOL MAY RESULT IN THE DEVELOPMENT OF
PROGRESSIVE LIVER INJURY WITH F IBROSIS. CHRONIC: NONE ADDITIONAL
INFORMATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
PHYS. SKIN: REMOVE CONTAMD CLTHG & WASH CONTAMD SKIN W/LG AMTS OF
WATER. IF IRRIT PERSISTS, CONT PHYS. INHAL: REMOVE FROM CONTAMD
AREA. IF BRTHG HAS STOPPED, GIVE ARTF RESP. CONT PHYS IMMED.
INGEST: INDUCE VOMIT OF CONSCIOUS PATIENT IMMED. CONT PHYS IMMED.
NOTE TO PHYS: MILD INTOXICATION OCCURS @ BLOOD LEVELS OF
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:3.3%
Extinguishing Media:USE CO*2/DRY CHEMICAL FOR SMALL FIRES; ALCOHOL
TYPE/ALL PURPOSE TYPE FOAMS FOR LARGE FIRES.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS AND
STRUCTURES.
Unusual Fire/Explosion Hazard:FLAMM LIQ; MAY RELEASE VAPS THAT FORM
FLAMM MIX WHEN TEMPS ARE AT/ABOVE FLASH POINT. VAP IS HVR/AIR & CAN
TRAVEL CONSIDERABLE DIST TO SOURCE OF IGNIT & (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE IGNITION SOURCES. WEAR SUITABLE
PROTECTIVE EQUIPMENT. SMALL SPILLS MAY BE FLUSHED W/LARGE
QUANTITIES OF WATER. LARGER SPILLS SHOULD BE COLLECTED FOR
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
STOR PRESS: ATMOSPHERIC. GEN: STORE IN COOL, WELL VENTILATED PLACE
AWAY FROM HEAT, SPARKS & FLAME.
Other Precautions:GROUND & BOND CNTNRS WHEN TRANSFERRING MATLS. USE
ONLY DOT APPRVD CNTNRS. EMPTY CNTNRS MAY RETAIN HAZ PROPERTIES.
HNDLG GEN: KEEP CNTNRS CLSD WHEN NOT IN USE. LOOSEN CLOSURE
CAUTIOUSLY BEFORE OPENING.USE SPK PROOF TOOLS & EXPLOSION(SUPDAT)
SOL IN H*2O: INSOLUBLE RESIN IN SOLUBLE CARRIER. EXPLO HAZ: FLASHBACK.
FIRST AID PROC: SEV POISONING OCCURS WHEN BLOOD ETHANOL LEVEL IS
0.3%-0.5%. ABOVE 0.5%, PATIENT WILL BE COMATOSE & DEATH CAN OCCU R.
HNDLG/STOR: PROOF EQUIP. AVOID BRTHGVAP. AVOID CONT W/EYES, SKIN &
CLTHG. PREC: CNDTNS TO AVOID: HEAT, SPKS, (ING 6)
* Physical/Chemical Properties *
Vapor Density:1.6
Evaporation Rate & Reference:3.6 (BU AC =1)
Solubility in Water:SUPP DATA
Appearance and Odor:CLEAR LIQUID, ALCOHOL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONCENTRATED NITRIC AND SULFURIC ACIDS, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE, AMMONIA. ORGANIC
ACIDS AND ALDEHYDES.
* Disposal Considerations *
Waste Disposal Methods:ALL DISPOSAL SHOULD BE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
* First Aid Measures *
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR,GIVE ART.RESIR.AS NEEDED.INGEST:GET MEDICAL ATTN.GIVE
LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE UNCONSCIOUS
PERS ON VOMIT.
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
* Physical/Chemical Properties *
HCC:Z3
Appearance and Odor:LIGHT STRAW COLORED-LIQUID,AROMATIC ODOR.
* Stability and Reactivity Data *
STRONG OXIDIZERS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED,GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL PERMITTED.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED ORGANIC RESPIRATOR
Ventilation:REQUIRED
Supplemental Safety and Health
WASTE DISPOSAL CONT'D: DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
* Product Identification *
Product ID:MAXAIR AUTOHALER
* Composition/Information on Ingredients *
Ozone Depleting Chemical:1
TRICHLOROMONOFLUOROMETHANE
Ozone Depleting Chemical:1
Ingred Name:PIRBUTEROL ACETATE
Fraction by Wt: 0.9%
Fraction by Wt: 0.5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE IRRITATION. FROSTBITE
MAY RESULT IF SPRAYED AT CLOSE RANGE. SKIN: FROSTBITE MAY RESULT IF
SPRAYED AT CLOSE RANGE. INHALATION: MAY CAUSE ANGINA,
HYPERTENSION/HYPOTENSION, PALPITATIONS & CARDIAC ARRHYTHMIAS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, RASH, ITCHING, NERVOUSNESS,
TREMORS, HEADACHE, DIZZINESS, DEPRESSION, ANXIETY, DRYMOUTH,
CONFUSION, INSOMNIA, WEAKNESS, FAINTING, ABDOMINAL PAIN/CRAMPS,
LOSS OF APPETITE, NAUSEA, VOMITING, NUMBNESS IN EXTREMITIES,
BALDNESS, BRUISING, FATIGUE, EDEMA, WEIGHT GAIN, FLUSHING.
* First Aid Measures *
First Aid:EYES: FLUSH W/PLENTY OF WATER. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. INGESTION: DON'T INDUCE VOMITING.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRES.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING. COOL FIRE EXPOSED CONTAINERS W/WATER SPRAY.
Unusual Fire/Explosion Hazard:PRESSURIZED CONTAINERS. AVOID EXTREME
HEAT.
* Accidental Release Measures *
Spill Release Procedures:IF CANS RUPTURE. EXTINGUISH IGNITION SOUCES.
VENTILATE AREA. CONTAIN & COVER W/ABSORBENT MATERIAL. COLLECT
MATERIAL & PLACE IN AN APPROVED CLOSED CONTAINER & SEAL.
*Handling and Storage *
Other Precautions:AVOID EYE/SKIN CONTACT & INHALATION, EXCEPT FOR
THERAPEUTIC APPLICATION. DON'T INGEST.
* Physical/Chemical Properties *
Spec Gravity:1.4
Appearance and Odor:SUSPENSION IN PROPELLANT MIXTURE, WHITE TO
OFF-WHITE W/FAINT ETHERAL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
PRESSURIZED CONTAINERS
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:HYDROCHLORIC ACID, HYDROFLUORIC ACID,
POSSIBLE CARBONYLFLUORIDE.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE ABSORBED & PARTIALLY FULL CANS AFTER
MIXING W/FLAMMABLE MATERIAL IN AN INDUSTRIAL/COMMERCIAL FACILITY.
THE FACILITY MUST BE CAPABLE OF HANDLING AEROSOL CANS. DON'T
PUNCTURE/BURN CANS IN A H OUSEHOLD INCINERATOR. (SEE SUPP)
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE M OR DM RESP AS REQD.
Ventilation:LOCAL OR GENERAL MECHANICAL
Other Protective Equipment:FULL SKIN & BODY PROTECTION.
Supplemental Safety and Health
* Product Identification *
Product ID:STANDARD HARDNESS SOLUTION, 0.2 E/M
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of Overexposure:EYE,SKN:IRRT. INHAL:IRRT TO MUCOSAL
MEMBRANES,INGEST:GI IRRT, NAUS.
* First Aid Measures *
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR; IF BRTHNG
DIFF GIVE OXYGEN. EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP&WATER. RMV CONTAM CLTHG&SHOES. INGEST:INDUCE VOMIT. RPT
UNTIL VOMIT IS C LEAR. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATTN.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:DRY CHEM, OR AS REQD FOR NEARBY FIRE.
Fire Fighting Procedures:USE SCBA PP MODE, FULL BODY PROTECTION.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:MAY BE WASHED TO SEWER OR WATERWAY DIRECTLY
DUE TO EXTREME DILUTION AND NEGLIGIBLE TOXICITY.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY AREA, AWAY FROM
SUNLIGHT CLOSED. AVOID STORAGE NEAR HEAT, ACIDS,OXIDIZERS.
Other Precautions:AVOID EYE,SKIN CONTACT. DO NOT INGEST OR INHALE. WASH
THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:1.0
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,COLORLESS LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:SEE SPILL INSTNS. ALWAYS DISPOSE IAW ALL LAWS &
REGS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITIONS;USE
NIOSH/MSHA APPROVED RESPIRATOR AS REQUIRED IF ABOVE PEL/TLV OR SCBA
IN AN ENCLOSED AREA.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE WASH STATION,WORK CLOTHING AND APRON AS
REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.KEEP AWAY FROM FOOD AND BEVERAGES.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:HEXAMETHLDISILOXANE
Ingred Name:OTHER COMPONENTS(NOT SPECIFIED)
* Hazards Identification *
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MILD IRRITATION OF
EYES,SKIN,RESPIRATORY TRACT;CHRONIC:NO DATA AVAILABLE.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:MILDLY IRRITATING TO UPPER RESPIRATORY TRACT.
Medical Cond Aggravated by Exposure:NO DATA AVAILABLE
* First Aid Measures *
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:USE SAND,CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR
WATER FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.(TOXIC GASES DURING
DECOMPOSITION.)
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;CONTAIN FREE
MATERIAL IF POSSIBLE;USE SUITABLE INERT ABSORBENT MATERIAL AND
RECOVER FOR PROPER DISPOSAL IN AN APPROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE.STORE AWAY
FROM FOOD AND BEVERAGES.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
* Physical/Chemical Properties *
HCC:F2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS,CLEAR LIQUID,LIGHT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:NONE SPECIFIED;CARBON MONOXIDE, CARBON
DIOXIDE,SIO*2 AND OTHER UNIDENTIFIED COMPONENTS ARE POSSIBLE.
* Disposal Considerations *
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES.DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOR CASUAL/OCCAS USE - TO AVOID BRTHG VAPS/SPRAY
MIST, OPEN WINDOWS & DOORS/USE OTHER MEANS TO ENSURE FRESH AIR
ENTRY DURING APPLICATION & DRYING. IF YOU EXPER EYE WATERING,
HDCH/DIZZ, INCR FRESH AIR,WEAR NIOSH/MSHA APPRVD RESP (SUPP DATA)
Ventilation:FOR REGULAR/CONTINUOUS USE - PROVIDE SUFFICIENT MECH(GEN)
&/OR LOC EXHST VENT TO MAINTAIN EXPOS BELOW TLV'S.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WHERE SPECIAL/UNUSUAL CNDTNS EXIST, (ING 7)
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING WASHROOM.
Supplemental Safety and Health
FIRE FIGHT PROC:OR EXPLO WHEN EXPOS TO EXTREME HEAT. IF WATER IS USED,
FOG NOZZ ARE PREF. EXPLO HAZ:GROUND/MAY BE MOVED BY VENT & IGNITED
BY PILOT LIGHTS, OTHER FLAMES, SPKS, HEATERS, SMOKING, ELEC MO
TORS/OTHER LOCATIONS DIST FROM MATL HNDLG POINT. RESP PROT:PROT
* Product Identification *
Preparer's Name:W.R. MALLARNEE
* Composition/Information on Ingredients *
Ingred Name:PROPIONIC ACID, 3-ETHOXY-, ETHYL ESTER; (ETHYL 3-ETHOXY
OSHA PEL:N/K
Fraction by Wt: 0-5%
Ingred Name:HYDROCARBON PROPELLANT; (PROPANE-ISOBUTANE MIXTURE)
ACGIH TLV:N/K
Ingred Name:OTHER PROT EQUIP:SEEK THE EXPERT ASSISTANCE OF AN
INDUSTRIAL HYGIENIST.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:EXCESSIVE INHAL OF VAPS
CAN CAUSE NASAL & RESP IRRIT, DIZZ, WEAK, FATG, NAUS, HDCH, POSS
UNCON & EVEN ASPHY. EYE CONT:CAN CAUSE SEV IRRIT, REDNESS, TEARING,
BLURRED VISION. INGEST:CAN CAUS E GI IRRIT, NAUS, VOMIT, DIARR.
SKIN CONT:CAN CAUSE IRRIT FOR SOME PERSONS. CHRONIC:REPORTS HAVE
ASSOC (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:RPTD & PRLNG OCCUP OVEREXP TO SOLVS
W/PERM BRAIN & NERV SYS DMG. SEVERE OVEREXP IN LAB ANIMALS HAS ALSO
CAUSED LIVER ABNORMS & DMG TO KIDNEYS, LUNGS & SPLEEN, HEART &
ADRENALS. INTENTIONAL MI SUSE BY DELIB CONCENTRATING & INHALING
CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:CAN CAUSE RESPIRATORY &/OR SKIN
REACTION.
* First Aid Measures *
First Aid:INHAL:REMOVE INDIVIDUAL TO FRESH AIR. IF BRTHG IS DFCLT,
ADMIN OXYG. IF BRTHG IS STOPPED, GIVE ARTF RESP & SEEK MED HELP.
INGEST:DO NO T INDUCE VOMIT (ASPIR OF MATL INTO LUNGS CAN CAUSE
PNEUMONIA, WHICH CAN BE FATAL). KEEP PERSON WARM, QUIET & GET MED
ATTN/POIS CTL CTR. SKIN:WASH W/SOAP & WATER OR VARIOUS HAND
CLEANERS & WASH CLTHG.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1%
Extinguishing Media:ALCOHOL FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFT. WATER MAY BE USED TO COOL CLSD CNTNRS TO
PVNT PRESS BUILD & POSS AUTOIGNIT(SUPDAT)
Unusual Fire/Explosion Hazard:EXTREMELY FLAMM. LEVEL 3 AEROSOL, OSHA
CLASS 1A. CLSD CNTNRS MAY EXPLODE &/OR AUTOIGNITE WHEN EXPOS TO
EXTREME HEAT, VAPS ARE HVR/AIR & MAY TRAVEL ALONG(SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES, VENTILATE
AREA, ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR ABSORBENT OR OTHER
ABSORBENT MATERIAL & TRANFER TO CLOSED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT PUNCTURE OR INCINERATE. DO NOT
FLAMES.
Other Precautions:STORE LARGE QUANTITIES IN BUILDING PROTECTED FOR
STORAGE OF FLAMMABLE LIQUIDS. AS W/ALL CHEMICALS, MINIMIZE PERSONAL
CONTACT.
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:<1 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT TO MODERATE
Appearance and Odor:TYPICAL SOLVENT PAINT.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS & HEAT.
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS, CARBON
DIOXIDE/CARBON MONOXIDE, VARIOUS HYDROCARBONS, NITROGEN COMPOUNDS,
ETC, WHEN BURNED.
* Disposal Considerations *
Waste Disposal Methods:MATERIAL COLLECTED ON ABSORBENT MATERIAL MAY BE
DEPOSITED IN A POSTED TOXIC SUBSTANCE LANDFILL I/A/W LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE UNDER NORMAL PROCESSING. USE NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST AT PROCESSING EQUIPMENT TO KEEP PARTICULATE
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:ZYTEC NYLON 6/6 NATURAL, NNS
* Composition/Information on Ingredients *
Ingred Name:POLYHEXAMETHYLENE ADIPAMIDE
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: NOT A PROBABLE ROUTE OF
EXPOSURE. INHALATION: VERY LOW TOXICITY. GRANULES NOT RESPIRABLE.
SKIN CONTACT: MOLTEN POLYMER CAUSES THERMAL BURNS. EYE CONTACT:
MECHANICAL IRRITATION. CHRONIC: NOCHRONIC EFFECTS KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) . SKIN: IF
MOLTEN POLYMER CONTACTS THE SKIN, COOL RAPIDLY WITH COLD WATER. DO
NOT ATTEMPT TO PEEL POLYMER FROM SKIN. OBTAIN MEDICAL ATTENTION FOR
* Fire Fighting Measures *
Extinguishing Media:WATER, CARBON DIOXIDE, FOAM, DRY CHEMICALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:LARGE MOLTEN MASSES MAY IGNITE
SPONTANEOUSLY IN AIR. WATER QUENCHING OF SUCH MASSES IS GOOD
PRACTICE.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP TO PREVENT SLIPPING HAZARDS.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:COOL, DRY PLACE. KEEP CONTAINERS
TIGHTLY CLOSED TO PREVENT MOISTURE ABSORPTION AND CONTAMINATION.
Other Precautions:
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE
Appearance and Odor:NATURAL (WHITE); NO ODOR.
Percent Volatiles by Volume:1
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZING AGENTS.
Hazardous Decomposition Products:AMMONIA, CARBON MONOXIDE, HYDROGEN
CYANIDE, ALDEHYDES.
* Disposal Considerations *
Waste Disposal Methods:INCINERATION OR LANDFILL IN COMPLIANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 4-6 RM VOL/HR) SHOULD
BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:WASHING FACILITIES.
Work Hygienic Practices:WASH HANDS WELL AFT HNDLG.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:STYRENE ACRYLATE COPLOYMER
Other REC Limits:NONE RECOMMENDED
Ingred Name:IRON OXIDE
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 MG/M3
Ingred Name:STYRENE POLYMER
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/INHAL:EXPECTED TO BE LOW HAZ FOR
RECOMMENDED HNDLG.EYES:NO SPECIFIC HAZ KNOWN.MAY CAUSE TRANSIENT
IRRIT.INGEST:EXPECTED TO BE LOW INGEST HAZ.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY
CLASSIFICATION:IARC/ACGIH/NTP/OSHA:NONE.
Effects of Overexposure:TRANSIENT EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:IF SYMPTOMATIC MOVE TO FRESH AIR. GET MED ATTN IF
SYMPTONS PERSIST. EYES:ANY MATL THAT CONTACTS EYE SHOULD BE WASHED
OUT IMMED W/WATER. GET MED ATTN. SKIN:WASH W/SOAP & WATER. GET MED
ATTN IF SY MPTOMS OCCUR. INGEST:DRINK 1-2 GLASSES OF WATER. SEEK
MED ATTN.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE (CO2), DRY CHEMICAL.
Fire Fighting Procedures:NONE.
Unusual Fire/Explosion Hazard:POWDERED MATERIAL MAY FORM EXPLOSIVE
DUST-AIR MIXTURES. COMBUSTIBLE SOILD.
* Accidental Release Measures *
Spill Release Procedures:DO NOT USE VACUUM CLEANER TO CLEAN UP SPILLS
OF POWDERED TONERS. THE VERY FINE PARTICLES CAN CAUSE A FIRE OR
EXPLOSION. SWEEP MATERIAL ONTO PAPER AND PLACE IN FIBER CARTON.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID BREATH DUST.USE W/ADEQUA
OF FIRE/DUST EXPLO CHEM/DYE/PARTM/PLAS INDUST".
Other Precautions:KEEP CNTNR CLOSED. MATL HAS NOT BEEN TESTED FOR
ENVIRO EFFEFTS.IN A SPILL SITUATION THIS MATL MAY BE VISUALLY
UNPLEASANT;HOWEVER IT IS NOT EXPECTED TO CAUSE ANY ADVERSE ENVIRO
EFFECTS.
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:NEGLIGIBLE
Vapor Density:N/APPLICAB
Spec Gravity:1.4-1.6
pH:N/APPL
Evaporation Rate & Reference:NEGLI (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SOLID (POWDER), BLACK COLOR, SLIGHT ODOR.
Percent Volatiles by Volume:NEGLIG
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:MINIMIZE DUST GENERATION/ACCUMULATION.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER. HAZ
COMBUST PROD:CARBON DIOXIDE, CARBON MONOXIDE, OXIDES OF NITROGEN,
OXIDES OF SULFUR.
* Disposal Considerations *
Waste Disposal Methods:CAN BE INCINERATE WHEN IN COMPLIANCE W/LOC
REGS.CONTRACT W/LICENSED CHEM DISPOS
AGENCY.DISCHARGE/TREATMENT/DISPOSAL MAY BE SUBJECT TO
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED IN NORMAL LABORATORY HANDLING. F
DUSTY CONDITIONS PREVAIL, WORK IN VENTILATION HOOD OR WEAR A
NIOSH/MSHA APPROVED DUST MASK.
Ventilation:LOCAL/MECHANICAL:RECOMMENDED
STATION.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. KEEP OUT OF
REACH OF CHILDREN.
Supplemental Safety and Health
* Product Identification *
Product ID:ALUMINUM NITRATE,NON-HYDRATE
Preparer's Name:MICHAEL RASZEJA
* Composition/Information on Ingredients *
Ingred Name:ALUMINUM NITRATE
* Hazards Identification *
Health Hazards Acute and Chronic:INHALATION: IRRITES THE RESPIRATORY
TRACT. INGESTION: TOXIC. SKIN: MAY CAUSE IRRITATION. EYES: MAY
CAUSE IRRITATION.
Effects of Overexposure:INHALATION:SYMPTOMS MAY INCLUDE SORE THROAT,
COUGHING, SHORTNESS OF BREATH. INGESTION: MAY CAUSE ABDOMINAL PAIN,
GASTROENTEITIS, METHAMOGOBINAMIA. SKIN: SYMPTOMS INCLUDE REDNESS,
ITCHING AND PAIN. EYE S: SYMPTOMS INCLUDE REDNESS ITCHING AND PAIN.
* First Aid Measures *
First Aid:INGESTION: IF SWALLOWED, IF CONSCIOUS, GIVE 1-2 GLASSESWATER
TO DRINK; INDUCE VOMITING AND CALL PHYSICIAN. NEVER GIVE ANYTHING
BY MOUTH TO UNCONSCIOUS PERSON. INHALATION: REMOVE TO FRESH AIR.I F
DISCO MFORT OR ILLNESS PERSISTS CALL PHYSICIAN. EYES: FLUSH
EYELIDS OCCASIONALLY. GET MEDICAL ATTENTION. SKIN: FLUSH WITH
WATER, THEN WASH WI TH MILD SOAP AND WATER.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE ANY MEDIA SUITABLE FOR EXTINGUISHING SUPPORTING
FIRE.
Fire Fighting Procedures:IN FIRE CONDITIONS, WEAR A NIOSH/MSHA APPROVED
SELF-CONTAINED BREATHING APPARATUS AND PROTECTIVE CLOTHING TO
PREVENT CONTACT WITH SKIN AND EYES. USE FLOODING AMOUNTS OF WATER
IN EARLY STAGES OF FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS OF ALUMINUM DUST OR VAPOR AND
EXIDES OF NITROGEN. THIS MATERIAL IS A STRONG OXIDIZING AGENT; CAN
REACT WITH ORGANIC MATERIALS OR RED UCING AGENTS TO CAUSE FIRE OR
EXPLOSION.
* Accidental Release Measures *
Spill Release Procedures:WEAR PROPER PROTECTIVE CLOTHING, SWEEP UP AND
PLACE IN A SUITABLE CONTAINER FOR DISPOSAL. AVOID DUST DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
COMBUSTIBLE MATERIALS. WASH THOROUGHLY AFTER HANDLING. KEEP
CONTAINER TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:READ LABEL ON CONTAINER BEFORE USING. DO NOT WEAR
CONTACT LENSES WHEN WORKING WITH CHEMICALS. DELIQUESCENT CRYSTALS.
REMOVE AND WASH CONTAMINATED CLOTHING PROMPTLY. FOR LABORATORY USE
ONLY. NOT FOR D RUG, FOOD OR HOUSEHOLD USE. KEEP OUT OF REACH OF
CHILDREN.
* Physical/Chemical Properties *
HCC:D1
B.P. Text:DECOMPOSES
Appearance and Odor:WHITE CRYSTALS; NO ODOR.
Percent Volatiles by Volume:NO DATA
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REDUCING AGENTS; ORGANIC MATERIALS.
Stability Condition to Avoid:EXCESSIVE TEMPERATURE AND HEAT.
COMBUSTIBLE MATERIALS.
Hazardous Decomposition Products:ALUMINUM DUST OR VAPOR AND OXIDES OF
NITROGEN.
* Toxicological Information*
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL LAWS.THESE DISPOSAL GUIDE LINES ARE
INTENDED FOR CATALOG-SIZE QUANTITIES ONLY. DISPOSE OF IN ACCORDANCE
WITH LOCAL, STATE, A ND FEDERAL REGULATIONS.
* MSDS Transport Information *
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED DUST MASK ABOVE TLV/PEL.
Ventilation:USE GUIDELINES RECOMMENDED BY AMERICAN CONFERENCE OF
GOVERNMENTAL INDUSTRIAL HYGIENISTS IN CURRENT (SEE SUPP DATA)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VENT:EDITION OF "INDUSTRIAL VENTILATION," CONSIDERING THE TLV.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:HYDRATED IRON OXIDE; (YELLOW IRON OXIDE) LIMITS AS IRON
ACGIH TLV:5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:DUST CONCENTRATIONS ABOVE THE
PERMISSIBLE EXPOSURE LIMIT MAY CAUSE TEMPORARY UPPER RESPIRATORY
TRACT DISCOMFORT. CHRONIC:NONE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:FOR INHALATION DISCOMFORT, REMOVE TO FRESH AIR.
OCCASIONALLY LIFTING THE LOWER AND UPPER LIDS. SKIN:WASH SKIN WITH
WATER AND MILD SOAP OR WATERLESS HAND CLEANER TO REMOVE IRON OXIDE
DUST. INGEST:ENTRY BY MOUTH IS NOT LIKELY TO PRODUCE ADVERSE
EFFECTS.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY
Fire Fighting Procedures:NORMAL FOG OR NOZZLE JET APPLICATION AND/OR
EXCLUSION OF AIR.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:VACUUM UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP IN CLOSED CONTAINERS.
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW, DRY POWDER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:BURY IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A NIOSH APPROVED RESPIRATOR APPROPRIATE WHERE
EXPOSURE EXCEEDS PEL/TLV.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . WASHING FACILITY.
Work Hygienic Practices:WASH ANY CONTACT AREA IMMEDIATELY. WASH HANDS
BEFORE EATING.
Supplemental Safety and Health
* Product Identification *
Product ID:BREEZE Z-4
CAGE:1M5S1
CAGE:1M5S1
* Composition/Information on Ingredients *
Ingred Name:SODIUM HYPOCHLORITE
ACGIH TLV:1 PPM
Ingred Name:SODIUM HYDROXIDE
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
ACGIH STEL:C2 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ROUTES OF ENTRY: EYES, SKIN &
INHALATION. OVEREXPOSURE MAY AGGRAVATE DISORDERS OF EYES, SKIN AND
RESPIRATORY SYSTEM. SIGNS AND SYMPTOMS OF EXPOSURE: FROM
IRRITATION, REDDENED SKIN TO BURNS AND ULCERAT ION.
Effects of Overexposure:OVEREXPOSURE MAY AGGRAVATE DISORDERS OF EYES,
SKIN AND RESPIRATORY SYSTEM.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
First Aid:EYE AND SKIN CONTACT: FLUSH CONTACTED AREA WITH WATER.
INHALATION: REMOVE TO FRESH AIR. IF NEEDED, GIVE ARTIFICIAL
RESPIRATION. INGESTION: DO NOT INDUCE VOMITING. RINSE MOUTH WITH
WATER. DRINK PLENTY OF WATER. IMMEDIATELY CALL PHYSICIAN.
* Fire Fighting Measures *
Flash Point:NONE.
Extinguishing Media:WATER.
Fire Fighting Procedures:WEAR NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:EVACUATE PERSONNEL, ELIMINATE IGNITION SOURCES
AND WEAR PROTECTIVE GEAR. CONTAIN SPILL. RECOVER FREE PRODUCT. MAY
BE NEUTRALIZED WITH REDUCING AGENTS. DILUTE WITH LARGE AMOUNTS OF
WATER.
Neutralizing Agent:REDUCING AGENTS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL DRY PLACE. RELIEVE
INTERNAL PRESSURE WEEKLY.
* Physical/Chemical Properties *
Vapor Density:N/A AIR=1
Evaporation Rate & Reference:N/A (BUTYL ACETATE=1)
Appearance and Odor:COLORLESS TO LIGHTLY COLORED LIQUID. ODOR NOT
SPECIFIED BY MFR .
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
METALS/METAL BLENDS, INORGANIC ACIDS, INORGANIC BASES, ORGANIC ACIDS,
ORGANIC BASES, ORGANIC MIXTURES.
* Disposal Considerations *
Waste Disposal Methods:FOLLOW FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH APPROVED ORGANIC VAPOR
RESPIRATORS/SELF CONTAINED BREATHING APPARATUS IF TLV IS EXCEEDED.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:ROUTINE LAB WEAR, EYE WASH STATION
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
Ingred Name:WATER
Ingred Name:BASIC FUCHSINE, PARAROSANILINE CHLORIDE (IARC CARCINOGEN
Ingred Name:CI. BASIC RED 9, MONOHYDROCHLORIDE, (IARC GROUP 2B,ANIMAL
Ingred Name:ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL, SYNASOL
Other REC Limits:5 MG/CUM
Ingred Name:BORIC ACID, ORTHOBORIC ACID
Ingred Name:RESORCINOL, M-DIHYDROXYBENZENE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION MAY OCCUR. EYES: MAY
CAUSE IRRITATION/BURNING. INGESTION: MAY BE FATAL. GASTROINTESTINAL
IRRITATION, BURNING, PULMONARY EDEMA, CNS DEPRESSION, & LOCAL
TISSUE NECROSIS MAY OCCUR. INHAL ATION: IRRITATION/BURNING MAY
OCCUR. MAY AFFECT THE RESPIRATORY TRACT, LIVER & KIDNEYS.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:DISCOLORATION OF SKIN, IRRITATION, BURNING,
DILATED PUPILS, IRREGULAR PULSE, REDUCED BODY TEMPERATURE,
EUPHORIA, CYANOSIS, UNCONSCIOUSNESS
Medical Cond Aggravated by Exposure:PHENOL: KIDNEY DISORDERS.
* First Aid Measures *
First Aid:SKIN: WASH W/WATER & SOAP. EYES: WASH W/COPIOUS AMOUNTS OF
WATER. INGESTION: GIVE PATIENT WATER IF CONSCIOUS. DON'T INDUCE
VOMITING. INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
CPR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
* Accidental Release Measures *
Spill Release Procedures:SMALL: MOP UP W/PAPER TOWEL & DISCARD. LARGE:
USE VERMICULITE/OTHER NON-COMBUSTIBLE ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS AT
ROOM TEMPERATURES. PROTECT FROM LIGHT.
Other Precautions:AVOID SKIN CONTACT.
* Physical/Chemical Properties *
Appearance and Odor:REDDISH PURPLE IN COLOR W/A SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, REDUCERS
Stability Condition to Avoid:HEAT, FLAME & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO2, CO
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED FOR NORMAL USE. NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST:MAINTAIN ADEQUATE VENTILATION.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:DEODORIZER, GARDEN APPLE.
* Product Identification *
Preparer's Name:CYNTHIA BORDELON
* Composition/Information on Ingredients *
Ingred Name:PROPANE
ACGIH TLV:ASPHYXIANT
Ingred Name:BUTANE
Ingred Name:ISOPROPYL ALCOHOL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY CAUSE TRANSIENT IRRITATION
IN EYES. HIGH CONCENTRATION OF VAPORS MAY CAUSE IRRITATION, NAUSEA,
DIZZINESS. MAY CAUSE DEFATTING OF SKIN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
First Aid:INHAL:REMOVE VICTIM TO FRESH AIR. APPLY ARTIFICIAL
RESPIRATION IF NECESSARY. GET MEDICAL ATTENTION. EYES:FLUSH WITH
PERSISTS. SKIN:WAS H AFFECTED AREAS W/SOAP & WATER. GET MEDICAL
ATTENTION IF IRRITATION PERSISTS. INGEST:DO NOT INDUCE VOMITING.
GET MEDICAL ATTENTION IMMEDIATELY.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:FOAM, DRY CHEMICAL, CO.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . KEEP CONTAINER COOL USING WATER SPRAY.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE. DO NOT EXPOSE TO
BURST.
* Accidental Release Measures *
Spill Release Procedures:SOAK UP SPILLED LIQUID WITH ABSORBENT
MATERIAL. PLACE IN CLOSED METAL DRUM. DISPOSE OF IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT STORE AT TEMPERATURES ABOVE
OF CHILDREN.
AEROSOLS. READ LABEL PRECAUTIONS CAREFULLY.
* Physical/Chemical Properties *
Evaporation Rate & Reference:FASTER (BUAC =1)
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR LIQUID/CHARACTERISTIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Hazardous Decomposition Products:CO, CO*2.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
APPROVED RESPIRATOR WITH ORGANIC VAPOR CANNISTER IS ACCEPTABLE. AN
APPROVED SELF-CONTAINED BREATHING APPARATUS OR AIR LINE RESPIRATOR
Ventilation:DO NOT USE IN CLOSED OR CONFINED SPACE. OPEN DOORS &/OR
Other Protective Equipment:PROTECTIVE CLOTHING, EYE WASH STATION &
SAFETY SHOWER. TO DETERMINE EXPOSURE LEVELS, MONITORING SHOULD BE
PERFORMED.
Work Hygienic Practices:DO NOT EAT, DRINK OR SMOKE IN WORK AREA. WASH
HANDS PRIOR TO EATING, DRINKING OR USING RESTROOMS. LAUNDER SOIL
CLOTHES.
Supplemental Safety and Health
NOTE: PROTECTIVE EQUIPMENT AND CLOTHING SHOULD BE SELECTED, USED AND
MAINTAINED ACCORDING TO APPLICABLE STANDARDS AND REGULATIONS. FOR
FUTHER INFORMATION CONTACT THE CLOTHING OR EQUIPMENT MANUFACTURER
OR THE VULCAN CHEMICAL TECHNICAL SERVICE DEPARTMENT.
* Product Identification *
Product ID:METHYLENE CHLORIDE (DICHLOROMETHANE)
CAGE:0YED2
* Composition/Information on Ingredients *
Ingred Name:METHYLENE CHLORIDE (SARA III)
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: METNHYLENE CHLORIDE
DEPRESSES THE CENTRAL NERVOUS SYSTEM. SKIN: PROLONGED OR REPEATED
CONTACT MAY CAUSE IRRITATION, DEFATTING OF SKIN & DERMATITIS. EYES:
VAPORS MAY IRRITATE EYES.
Explanation of Carcinogenicity:METHYLENE CHLORIDE IS LISTED ON THE IARC
& NTP CARCINOGEN LIST BUT NOT BY OSHA.
Effects of Overexposure:INHALATION: NAUSEA, HEADACHE, VOMITING,
NUMBNESS AND TINGLING IN ARMS AND LEGS AND RAPID HEARTBEAT, LOSS OF
CONSCIOUSNESS AND DEATH HAVE OCCURED.
Medical Cond Aggravated by Exposure:ALCOHOLISM, ACUTE AND CHRONIC
LIVER, CHRONIC LUNG DISEASE, ANEMIA, CORONARY DISEASE OR RHYTM
DISORDERS OF THE HEART.
* First Aid Measures *
First Aid:INHALATION:REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED,
ADMINISTER ARTIFICIAL RESPIRATION. CALL A PHYSICIAN. SKIN: REMOVE
CONTAMINATED CLOTHING. WASH EXPOSED AREA WITH LARGE AMOUNTS OF
MIN. IF IRRITATION PERSISTS, CALL PHYSICIAN. INGESTION:DO NOT
INDUCE VOMITING. CONTACT PHYSICIAN OR EMERGENCY MEDICAL FACILITY
IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:WATER FOG, DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF-CONTAINED
BREATHING APPARATUS DUE TO THERMAL DECOMPOSITION PRODUCTS AND AVOID
SKIN CONTACT.
Unusual Fire/Explosion Hazard:CONCENTRATED VAPORS CAN BE IGNITED BY
HIGH INTENSITY HEAT SOURCE.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE THE AREA. VENTILATE, AND AVOID
BREATHING VAPORS. DIKE AREA TO CONTAIN SPILL. CLEAN UP AREA (WEAR
PROTECTIVE CLOTHING) BY MOPPING OR WITH ABSORBENT MATERIAL & PLACE
IN CLOSED CONTAINER FOR DIS POSAL. DO NOT FLUSH TO SEWER. AVOID
GROUND WATER.
*Handling and Storage *
Handling and Storage Precautions:STORE LABELED CONTAINERS IN A COOL,
DRY, WELL-VENTILATED AREA OUT OF SUNLIGHT. PREVENT WATER OR MOIST
AIR FROM ENTERING STORAGE TANKS OR CONTAINERS.
Other Precautions:DO NOT CUT OR WELD ON EMPTY OR FULL DRUMS. CONTACT
WITH ALUMINUM PARTS IN A PRESSURE FLUID SYSTEM MAY CAUSE VIOLENT
REACTIONS. CONSULT SUPPLIER FOR INFORMATION. VAPORS ARE HEAVIER
THAN AIR & WILL LOCA TE IN LOW AREAS. DO NOT REMOVE LABELS.
* Physical/Chemical Properties *
HCC:T4
Vapor Density:2.9
Evaporation Rate & Reference:0.7 (ETHER=1)
Appearance and Odor:COLORLESS CLEAR LIQUID; MILDLY SWEET ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, OXYGEN, NITROGEN PEROXIDE, SODIUM, POTASSIUM, & OTHER
OXIDIZERS & REACTIVE METALS.
Stability Condition to Avoid:CONTACT WITH OPEN FLAME, ELECTRIC ARCS, OR
OTHER HOT SURFACES WHICH CAN CAUSE THERMAL DECOMPOSITION.
Hazardous Decomposition Products:HYDROGEN CHLORIDE,PHOSGENE, CHLORIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:RECOVERED LIQUID MAY BE SENT TO A LICENSED
RECLAIMER OR INCINERATED. CONTAMINATED MATERIAL MUST BE DISPOSED OF
IN A PERMITTED WASTE MSNAGEMENT FACILITY. CONSULT FEDERAL, STATE OR
LOCAL DISPOSAL AUTHOR ITIES FOR APPROVED PROCEDURES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT APPLICABLE. NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST: SUFFICIENT.
FACESHIELD .
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . RUBBER CLOTHES, E.G. APRON, OPTIONAL.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
SUPDAT: FOLLOW W/OLIVE, VEGETABLE OR MINERAL OIL. NEVER GIVE ANYTHING
BY MOUTH TO UNCON PERSON. CALL PHYS IMMED.
* Product Identification *
Product ID:BAR GLASS CLEANER
CAGE:SYSCO
CAGE:SYSCO
* Composition/Information on Ingredients *
PENTAHYDRATE) TLV MG/M3: 2 (AS NAOH)
= Wt:5.
Ingred Name:IMPURITIES
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN AND EYES: MODERATE
IRRITANT. MAY CAUSE CHEMICAL BURNS TO EYES. IMMEDIATE WATER
FLUSHING IS VITAL IN CASE OF EYE CONTACT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYG/ARTIFICIAL RESPIRATION) . SKIN: FLUSH W/COPIOUS AMTS OF WATER.
. FOR EYE CONT OR INGEST, GET MEDICAL ATTENTION AT ONCE. EYES:
IMMED FLUSH W/PLENTY OF COOL RUNNING WATER. REMOVE CONT LENSES IF
EXTERNAL: FLUSH WELL W/WATER. IF IRRIT DEVELOPS/PERSISTS, CONSULT A
PHYS . IF SPILLED ON CLTHG, REMOVE & WASH BEFORE RE-USE. INTERNAL:
IF SWALLOWED, DO NOT INDUCE VOMIT. DRINK LG QTYS OF MILK, MILK OF
MAGNESIA, RAW EGGS OR WATER. (SUPDAT)
* Fire Fighting Measures *
Extinguishing Media:PRODUCT IS NOT FLAMMABLE. USE CO*2 OR DRY
CHEMICALS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DO NOT MIX WITH ACIDIC CHEMICALS.
SOLUTIONS ARE MODERATELY ALKALINE.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP SPILLED MATERIAL AND PLACE IN
SUITABLE CONTAINER. FLUSH AREA WITH WATER.
*Handling and Storage *
Handling and Storage Precautions:ALKALINE MATERIAL. HANDLE AS FOR ALL
STRONG CHEMICALS. STORE IN A COOL, DRY AREA.
Other Precautions:SAFE WHEN USED PROPERLY. KEEP OUT OF REACH OF
CHILDREN.
* Physical/Chemical Properties *
Appearance and Odor:WHITE TO OFF-WHITE MIXTURE OF GRANULES AND POWDER,
SLIGHTLY DUSTY, ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:DO NOT MIX WITH ACIDIC CHEMICALS; FUMES OF
TOXIC CHLORINE GAS COULD BE RELEASED.
Hazardous Decomposition Products:OR BYRPODUCTS: STABLE.
* Disposal Considerations *
Waste Disposal Methods:CONSULT FEDERAL, STATE AND LOCAL REGULATIONS FOR
PROPER METHOD OF DISPOSAL.
* Regulatory Information *
MATERIALS USED IN MAKING THIS PRODUCT MAY CONTAIN SMALL AMOUNTS OF
THE STATE OF CALIFORNIA.
| 1 | gloves_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Item Description Information
*
*
Ingredients
*
Other REC Limits: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH STEL: N/K (FP N)
------------------------------
% low Wt: 1.
% high Wt: 5.
Other REC Limits: N/K (FP N)
OSHA PEL: see Table Z-3
OSHA STEL: N/K (FP N)
ACGIH TLV: 2 MG/M3
ACGIH STEL: N/K (FP N)
------------------------------
% low Wt: 5.
Other REC Limits: N/K (FP N)
------------------------------
Percent by Wt: .1
Other REC Limits: N/K (FP N)
OSHA PEL: 0.1 MG/M3
OSHA STEL: N/K (FP N)
ACGIH STEL: N/K (FP N)
-----------------------------
Other REC Limits: SKIN NOTATION
OSHA PEL: see Table Z-2
OSHA STEL: N/K (FP N)
ACGIH STEL: N/K (FP N)
------------------------------
Other REC Limits: N/K (FP N)
OSHA STEL: N/K (FP N)
------------------------------
% low Wt: 1.
% high Wt: 5.
OSHA PEL: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
ACGIH STEL: N/K (FP N)
------------------------------
Other REC Limits: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH TLV: 5 MG/M3;2 PPM
ACGIH STEL: N/K (FP N)
------------------------------
Other REC Limits: N/K (FP N)
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE: EYES: CAN CAUSE IRRITATION. SKIN: CAN CAUSE
IRRITATION. MAY CAUSE DEFATTING OF THE SKIN. PROLONGED OR REPEATED SKIN
CONTACT MAY CAUSE DERMATITIS. INHALATION: ANESTHETIC. CAN CAUSE IRRITATION OF
RESPIRATORY TRACT OR ACUTE NERVOUS SYSTEM DEPRESSION CHARACTERIZED BY THE
FOLLOWING PROGRESSIVE STEPS IF SEVERE OVEREXPOSURE IS CONTINUED: HEADACHE,
DIZZINESS, STAGGERING GAIT, CONFUSION OR UNCONSCIO USNESS. INGESTION: IF
SWALLOWED, CONSULT A PHYSICIAN IMMEDIATELY. CHRONIC: REPORTS HAVE ASSOCIATED
REPEATED AND PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE, (EFFECTS OF OVEREXPOSURE)
Explanation Of Carcinogenicity: THIS PRODUCT HAS NOT BEEN TESTED AS A WHOLE FOR
CARCINOGENICITY. THE COBALT COMPOUND IN THIS PRODUCT HAS NOT BEEN
SPECIFICALLY IDENTIFIED AS CAUSING CANCER IN HUMANS OR ANIMALS. HOWEVER, IARC
HAS LIST ED "COBALT AND COBALT COMPOUNDS" AS POSSIBLY CARCINOGENIC (GROUP 2B)
BASED UPON LABORATORY ANIMAL STUDIES.
Signs And Symptions Of Overexposure: HEALTH HAZARDS: LIVER AND KIDNEY DAMAGE.
THERE ARE REPORTS THAT LONG-TERM REPEATED EXPOSURE TO XYLENE MAY RESULT IN
SOME LOSS OF HEARING. THERE ARE REPORTS THAT LONG-TERM REPEATED EXPOSURE TO
TOLUENE MAY RESULT IN SOME LOSS OF HEARING. TOLUENE APPEARS ON THE NAVY
OCCUPATIONAL CHEMICAL REPRODUCTIVE HAZARDS LIST. SEEK CONSULTATION FROM
APPROPRIATE HEALTH PROFESSIONALS CONCERNING LATEST HAZARD LIST I NFORMATION
AND SAFE HANDLING AND EXPOSURE INFORMATION (FP N).
Medical Cond Aggravated By Exposure: ASTHMA AND OTHER RESPIRATORY AILMENTS.
CHEMICAL SENSITIZATION.
MINUTES WHILE LIFTING EYELIDS. TAKE TO PHYSICIAN FOR MEDICAL TREATMENT. SKIN:
WASH AFFECTED AREA WITH SOAP AND WATER. REMOVE CONTAMI NATED CLOTHING AND
WASH BEFORE REUSE. CONSULT A PHYSICIAN IF IRRITATION DEVELOPS OR PERSISTS.
INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM AND QUIET.
NOTIFY A PHYSICIAN. INGESTION: I F SWALLOWED, CALL A PHYSICIAN OR POISON
CONTROL CENTER IMMEDIATELY.
*
Handling and Disposal
*
Spill Release Procedures: EVACUATE ALL NON-ESSENTIAL PERSONNEL & REMOVE ALL
SOURCES OF IGNITION (FLAMES, HOT SURFACES, ELECTRICAL, STATIC &
FRICTIONAL SPARKS). VENTILATE AREA. EQUIP CLEAN-UP CREW W/APPROP PROT EQUIP.
AVOID BRE ATHING VAPORS. AVOID SKIN CONTACT. PREVENT ENTRY INTO DRAINS,
SEWERS & WATERWAYS. NOTIFY APPROPRIATE AUTHORITIES IF NECESSARY. CONTAIN
& REMOVE W/INERT ABSORBENT & NON-SPARKING TOOLS.
Waste Disposal Methods: RECYCLE, FUEL BLEND/INCINERATE. DISPOSE OF I/A/W APPLIC
LAWS & REGS. IT IS THE RESPONSIBILITY OF THE OWNER OF WASTE TO DISPOSE OF
IT PROPERLY. LAB ANALYSIS IS REC TO PROFILE WASTE FOR PROPER DISP DETE
WASTE CHARACTERISTICS: IGNITABL E. DISPOSE OF I/A/W LOC, STATE, & FED
REGS (FP N).
Handling And Storage Precautions: USE ONLY W/ADEQ VENT. AVOID PRLNG BRTHG OF
VAPS. WEAR APPROP, PROPERLY FITTED RESP (NIOSH APPRVD) DURING & AFTER
APPLICATION UNLESS AIR MONITORING DEMONSTRATES THAT VAP/MIST LEVELS ARE BELOW
APPLIC EX POS LIMS. FOLLOW RESP MFR'S DIRECTIONS FOR USE. CAN CAUSE IRRIT TO
EYES, SKIN, NOSE & THROAT.
Other Precautions: AVOID CONT W/EYES & CLTHG. AVOID PRLNG/RPTD CONT W/SKIN.
USE GROUNDING & BONDING CONNECTION WHEN TRANSFERRING MATL TO PVNT STATIC
DISCHARGE, FIRE/EXPLO. AVOID FREE FALL OF LIQ IN EXCESS OF A FEW INCHE S. USE
STORE LGE QTYS IN BLDGS DESI GNED TO (SUP DAT)
*
Fire and Explosion Hazard Information
*
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures: WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM HEAT, ELEC EQUIP, SPKS & OPEN
FLAMES. CLSD CONTR MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. WATER SPRAY MAY
BE IN EFFECTIVE. WATER MAY BE USED TO COOL CLSD CONTRS TO PVNT PRESS
BUILD-UP/POSS AUTOIGNIT/EXPLO WHEN EXPOSED (OTHER INFO)
*
*
Respiratory Protection: WHEN SPRAY APPLIED & WHEN USED IN LIMITED VENT
AREAS, WEAR NIOSH APPRVD ORG VAP/PARTICULATE RESP DESIGNED TO REMOVE
COMBINATION OF PARTICULATE, GAS & VAP. WHEN USED IN CONFINED AREAS/POORLY
VENTILATED AREAS, USE NIOSH APPRVD AIR LINE RESP/HOOD. DURING
SANDING/GRINDING OPERATIONS, USE NIOSH APPRVD PARTICULATE RESP TO REMOVE
SOLID AIRBORNE (OTHER INFO)
Ventilation: PROVIDE GEN DILUTION/LOC EXHST VENT IN VOL & PATTERN TO KEEP
AIR CONTAMINANT CONC BELOW CURRENT APPLIC OSHA SFTY & HLTH REQS IN
MIXING, (ECOLOGICAL INFO)
REPEATED CONTACT.
Other Protective Equipment: ANSI APPROVED EMERGENCY EYEWASH AND DELUGE SHOWER
(FP N). EDUCATE AND TRAIN EMPLOYEES IN THE SAFE USE OF THIS PRODUCT. AN APRON
MAY BE APPROPRIATE TO PROTECT AGAINST SKIN CONTACT.
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING. IT IS GOOD INDUSTRIAL
HYGIENE PRACTICE TO MINIMIZE SKIN CONTACT. PREVENT PROLONGED SKIN CONTACT
WITH CONTAMINATED CLOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSE.
KEEP AWAY FROM HEAT, SPARKS & OPEN FLAME. KEEP CONTRS CLOSED WHEN NOT IN
USE. KEEP CLOSURES TIGHT & UPRIGHT TO PREVENT LEAKAGE. EMPTIED CONTRS MAY
RETAIN H AZ RESIDUE. FOLLOW ALL HAZ PREC IN THIS MSDS UNTIL CONTR IS THORO
CLEANED/DESTROYED. (OTHER INFO)
*
Physical/Chemical Properties
*
Solubility in Water: NEGLIGIBLE
Appearance and Odor: OPAQUE LIQUID WITH SOLVENT ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: SEE HAZARDOUS DECOMPOSITION PRODUCTS.
Materials To Avoid: STRONG OXIDIZERS.
Hazardous Decomposition Products: MAY PRODUCE HAZARDOUS FUMES WHEN HEATED TO
DECOMPOSITION AS IN WELDING. FUMES MAY CONTAIN THE FOLLOWING: CARBON
MONOXIDE, CARBON DIOXIDE AND OTHER TOXIC VAPORS DEPENDING UPON THE
TEMPERATURE REACHED.
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
Toxicological Information: SEE HEALTH HAZARDS SECTION. THIS PRODUCT CONTAINS
ONE OR MORE REPORTED CARCINOGENS OR SUSPECTED CARCINOGENS.
*
Ecological Information
*
Ecological: N/P -- OTHER INFORMATION: AIR MONITORING OF THE WORKPLACE MAY BE
REQUIRED TO DETERMINE APPROPRIATE RESPIRATOR SELECTION. -- VENTILATION:
APPLICATION AND CURING AREAS, AND TO REMOVE DECOMPOSITION PRODU CTS DURING
WELDING AND FLAME CUTTING ON SURFACES COATED WITH THIS PRODUCT. --
*
*
HAZARD CLASS: 3. DOT LABEL: FLAMMABLE LIQUID. DOT PACKAGING GROUP: PG II.
U.S. POSTAL SERVICE: WILL NOT HANDLE.
*
Regulatory Information
*
Sara Title III Information: THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS
*
Other Information
*
Other Information: PROD CLASS: RED OXIDE H/S UNIVERSAL. INFO: HLTH=2; FLAMM=3;
REACTIVITY=0. SUP DAT: TO AVOID SPONT COMBUST DURING TEMPORARY STOR, SOAK
SOILED RAGS & WASTE IMMED AFTER USE IN WATER-FILLED, CLSD CON TR. FIRE
FIGHT PROC: TO EXTREME HEAT. IF WATER IS USED, FOG NOZZ ARE PREF. DO NOT
APPLY TO HOT SURFS. NEVER USE WELDING/CUTTING TORCH ON/NEAR PROD CONTR (EVEN
EMPTY) BECAUSE PROD (EVEN RESIDUE) CAN IG NITE EXPLO. RESP PROT: PARTICLES OF
SANDING DUST. USE NIOSH APPRVD RESPS WHEN FLAME CUTTING, WELDING/BRAZING MATL
(ECOLOGICAL INFO )
*
HAZCOM Label
*
Company Name: HENTZEN COATINGS INC
Label Required IND: Y
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE: EYES: CAN CAUSE IRRITATION. SKIN: CAN
CAUSE IRRITATION. MAY CAUSE DEFATTING. INHALATION: ANESTHETIC. CAN CAUSE
IRRITATION OF RESPIRATORY TRACT OR ACUTE NERVOUS SYSTEM DEPRESSION CHAR
ACTERIZED BY: HEADACHE, DIZZINESS, STAGGERING GAIT, CONFUSION OR
UNCONSCIOUSNESS. INGESTION: IF SWALLOWED, CONSULT A PHYSICIAN IMMEDIATELY.
CHRONIC: REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED OCCU PATIONAL
OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE,
LIVER AND KIDNEY DAMAGE. TOLUENE APPEARS ON THE NAVY OCCUP CHEM REPRO HAZS
LIST (FP N). SKIN: PROLONGED OR REPEATED CO NTACT MAY CAUSE DERMATITIS.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT APPLICABLE. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:IF HEATED TO FLASH POINT.
Other Protective Equipment:HEAT RESISTANT APRON.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Preparer's Name:ROGERS
* Composition/Information on Ingredients *
Ingred Name:WOOD ROSIN (ALL GRADES); (WOOD ROSIN)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL:PROLONGED EXPOSURE TO
FUMES OF HEATED MATERIAL MAY CAUSE MILD IRRITATION. INGEST:CONSULT
MD. SKIN: PROLONGED EXPOSURE MAY CAUSE MILD SKIN IRRITATION.
EYES:PROLONGED EXPOSURE TO FUMES OF H EATED MATERIAL MAY CAUSE MILD
IRRITATION. CHRONIC: NONE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
W/SOAP & WATER. INHAL:REMOVE AFFECTED PERSON TO FRESH AIR.
INGEST:CONSULT MD.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR
FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . TREAT AS WOOD FIRE.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:ALLOW TO COOL & PLACE IN WASTE CONTAINER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED & AWAY FROM
HEAT & OPEN FLAME.
Other Precautions:NONE.
* Physical/Chemical Properties *
HCC:N1
Appearance and Odor:DARK AMBER; SLIGHT PINE ODOR.
Percent Volatiles by Volume:0.1
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
* Disposal Considerations *
Waste Disposal Methods:LANDFILL. DISPOSAL MUST BE IN ACCORDANCE W/
FEDERAL, STATE & LOCAL REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A PROPERLY FITTED VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA. DON'T PERMIT ANYONE W/O
PROTECTION IN THE PAINTING AREA.
Ventilation:SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:COVERALLS
Supplemental Safety and Health
ACTIVATED W/ISOCYANATE, WEAR A POSITIVE PRESSURE SUPPLIED AIR
RESPIRATOR.
* Product Identification *
Preparer's Name:T R LOUER
* Composition/Information on Ingredients *
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred
Name:2-((4-CHLORO-2-NTROPHENYL)AZO)-N-(2-OXO-5-BENZIMIDAZOLINYL)-AC
Ingred Name:QUATERNARY AMMONIUM COMPOUNDS, BENZYL(HYDROGENATED TALLOW A
KYL)DIMETHYL, CHLORIDES, COMPDS. W/HECTORITE; CLAY
Ingred Name:VOLATILE ORGANIC CONTENT: 2 LBS/GAL
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE & THROAT IRRITATION.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. SKIN: IRRITATION, DERMATITIS. EYES:
IRRITATION, BURNING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, EYE WATERING,
HEADACHE, NAUSEA, DIZZINESS, LOSS OF COORDINATION, DISCOMFORT,
BURNING.
* First Aid Measures *
First Aid:INGESTION: CALL A PHYSICIAN IMMEDIATELY & HAVE NAMES OF
INGREDIENTS AVAILABLE. INHALATION: REMOVE TO FRESH AIR. SKIN: WASH
MEDICAL AT TENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE THE FLASH POINT, EMITS
FLAMMABLE VAPORS WHICH, WHEN MIXED W/AIR CAN BURN/EXPLODE. FINE
MISTS/SPRAYS MAY BE FLAMMABLE AT TEMP < FLASH POINT.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. REMOVE IGNITION SOURCES.
PREVENT SKIN CONTACT & BREATHING OF VAPORS. WEAR A PROPERLY FITTED
VAPOR/PARTICULATE RESPIRATOR. CONFINE & REMOVE W/INERT ABSORBENT.
(SEE SUPP)
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM HEAT & OTHER IGNITION
SOURCES. CLOSE CONTAINERS AFTER EACH USE. GROUND CONTAINERS WHEN
POURING. WASH THOROUGHLY AFTER HANDLING.
DRY COATING W/O NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE
VENTILATION. OBSERVE LABEL PRECAUTIONS.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:(SUPP)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO2, SMOKE, OXIDES OF METALS.
* Disposal Considerations *
Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE WATER
SYSTEMS. INCINERATE ABSORBED MATERIAL IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE IN CLOSED CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE FACE MASK IF HEAVY VAPOR PRESENT.
Ventilation:LOCAL/MECHANICAL EXHAUST
Supplemental Safety and Health
* Product Identification *
CAGE:ACESU
CAGE:ACESU
* Composition/Information on Ingredients *
Ingred Name:METHYLENE CHLORIDE(SARA III)
Other REC Limits:A2 CARCINOGEN
Ingred Name:STODDARD SOLVENT
Ingred Name:PERCHLOROETHYLENE (TETRACHLOROETHYLENE) (SARA III)
Fraction by Wt: 5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. INHALATION: MUCOUS
MEMBRANES IRRITATION, NAUSEA & UNCONSCIOUSNESS.
Explanation of Carcinogenicity:METHYLENE CHLORIDE/PERCHLOROETHYLENE ARE
CONSIDERED TO BE AN A2 CARCINOGEN BY ACGIH.
Effects of Overexposure:SKIN: IRRITATION. INHALATION: IRRITATES MUCOUS
MEMBRANES, NAUSEA & UNCONSCIOUSNESS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO WELL VENTILATED AREA.
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:CO2, DRY CHEMICAL
Fire Fighting Procedures:NOT WATER SOLUBLE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. PUMP INTO TANKS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN DRY PLACE, AVOIDING HIGH
TEMPERATURES. AVOID CLOSED AREAS WHEN USING. ALWAYS HAVE ADEQUATE
VENTILATION IN WORK AREA.
* Physical/Chemical Properties *
Vapor Density:4
Evaporation Rate & Reference:(WATER = 1): 0.9
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WATER WHITE LIQUID, CHLORINATED HYDROCARBON ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:FLUSH SMALL LEAK INTO DRAINS USING COPIOUS
QUANTITIES OF WATER OR ABSORB W/SAND OR OTHER ABSORBENT MATERIALS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR W/DUST
FILTER/ DUST MASK, FOR CONCENTRATIONS ABOVE EXPOSURE LIMITS. MOLTEN
METAL HNDLG REQS USE OF BOTH PRIMARY & SECONDARY PERSONAL PROT
EQUIP. REFER TO "ALUMINUM A SSOCIATION" GUIDELINES.
Ventilation:SPECIAL VENT PROVISIONS MAY BE REQD TO AVOID E
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATL TO AVOID: AMMONIUM NITRATE. FINELY DIVIDED ALUMINUM CAN THERMITE
IN PRESENCE OF OXIDES OF COPPER, OF LEAD/OF IRON. EFTS OF OVEREXP:
PRDCE SYMPS OF METAL FUME FEVER. HIGH CONC OF MANGANESE DUST CA N
AFFECT CNS (APATHY, DROW, WEAK & OTHER PROBLEMS RESEMBLING
PARKINSONISM).
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: SEE ING
Fraction by Wt: SEE ING
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: SEE ING
OSHA PEL:5 MG/M3 DUST,C
ACGIH TLV:5 MG/M3 DUST
Fraction by Wt: SEE ING
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:OTHER PREC: "RECOM FOR STOR & HNDLG OF ALUMINUM POWDERS &
Ingred Name:ALUMINUM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: ALUMINUM & SILICON DUSTS ARE
CONSIDERED NUISANCE PARTICULATES WHICH HAVE LITTLE ADVERSE EFTS ON
LUNGS WHEN EXPOS ARE KEPT UNDER REASONNABLE CTL. SKIN: CAN CAUSE
BURNS. EYE: ALUMINUM DUST CAN IR RITATE EYES (MECH ABRASION).
ALUMINUM FUMES GENERATED DURING WELD/MELT OPERATIONS PRESENT LOW
HLTH (EFTS OF OVEREXP)
CARCIN
Effects of Overexposure:HLTH HAZ: RISKS. MIG WELD/PLASMA ARC CUTTING OF
ALUMINUM ALLOYS CAN GENERATE OZONE, NITRIC OXIDES & ULTRAVIOLET
RADIATION. OZONE OVEREXP MAY RSLT IN MUC MEMB IRRIT/PULM
DISCOMFORT. UV RADIA CAN CAUSE SKIN ERYTHEMA & WELDERS FLASH. HIGH
CONC OF FRESHLY FORMED FUMES OF MAGNESIUM OXIDES & MANGANESE OXIDES
& CAN (SUPDAT)
* First Aid Measures *
First Aid:INHAL: GO TO A VENTILATED AREA. IF DISCOMFORT PERSISTS, GET
MED ATTN. REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O2/ARTF RESP) .
SKIN: RINSE WITH PLENTY OF COLD WATER. IF BURN IS SEV, SEEK MED ATT
CONSULT A PHYS. INGEST: CALL MD IMMED .
* Fire Fighting Measures *
Extinguishing Media:IN CASE OF AN ALUMINUM FIRE, USE A CLASS D DRY
POWDER EXTING/DRY SAND. DO NOT USE WATER/HALOGENATED EXTING MEDIA.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL PROT
EQUIPMENT.
Unusual Fire/Explosion Hazard:NOT A FIRE HAZ UNLESS IN FINELY DIVIDED
FORM. ALUMINUM DUST CAN PRESENT A SEVERE EXPLOSION HAZARD IF
DISPERSED IN AIR.
* Accidental Release Measures *
Spill Release Procedures:RECYCLE. FINELY-DIVIDED ALUMINUM MAY BE
REACTIVE & ITS HAZARD CHARACTERISTIC SHOULD BE DETERMINED PRIOR TO
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:INGOTS & METAL SCRAP SHOULD BE THORO
DRIED PRIOR TO REMELTING DUE TO EXPLO HAZ. CHECK METAL TEMP W/USUAL
METHS BEFORE HNDLG IT.
Other Precautions:HOT ALUMINUM DOES NOT PRESENT ANY WARNING COLOR
CHANGE; SPECIAL CAUTION SHOULD THEREFORE BE TAKEN IN CASE METAL
WOULD BE HOT. FOR MORE INFO ON HNDLG & STOR OF ALUMINUM, REQUEST A
COPY OF "GUIDELINES F OR HNDLG MOLTEN ALUMINUM" & (ING 6)
* Physical/Chemical Properties *
Spec Gravity:2.5-2.9(H*2O=1)
Appearance and Odor:GREY TO SILVER SOLID; ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
FINELY DIVIDED ALUMINUM MAY EXPLODE WHEN MIXED W/HALOGENATED ACIDS,
HALOGENATED SOLVS, BROMATES, IODATES/ (SUPP DATA)
Stability Condition to Avoid:MOLTEN ALUMINUM MAY EXPLODE UPON CONT
W/WATER.
Hazardous Decomposition Products:FINELY DIVIDED ALUMINUM REACTS
W/HALOGENATED ACIDS, WATER AND SODIUM HYDROXIDE TO PRODUCE HYDROGEN
GAS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE I/A/W FEDERAL, STATE, OR LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPRVD PARTICLE MASK TO AVOID
BRTHG SPRAY MIST OR SANDING DUST, IF LOC VENT IS ADEQ TO KEEP TLV
W/IN ACCEPTABLE LIMITS. IF LOC VENT IS NOT ADEQ, USE NIOSH/NSHA
APPRVD RESP FOR ORG VAP S UPPLIED/SCBA IS RECOMMENDED.
Ventilation:LOCAL EXHAUST SUFFICIENT TO KEEP TLV BELOW PRESCRIBED
LIMITS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MRF TRADE NAME/PART NO: ALL COLORS.
* Product Identification *
Preparer's Name:JULIAN SCHAFER
CAGE:KELLY
CAGE:KELLY
* Composition/Information on Ingredients *
Ingred Name:PROPIONIC ACID, 2-METHYL-,MONOESTER
Fraction by Wt: <5%
Ingred Name:HEXYLENE GLYCOL
Fraction by Wt: <5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: DIZZINESS, HEADACHE, NAUSEA,
CONFUSION, IRRITATION TO UPPER RESPIRATORY TRACT, UNCON, SKIN AND
EYE IRRITATION. CHRONIC: NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SEE YOUR PHYS FOR SPECIFIC MED
OPINION REGARDING YOUR CONDITION.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. RESTORE BREATHING, CONSULT PHYS.
ATTN. SKIN: WIPE OFF WITH RAG. WASH THOROUGHLY WITH SOAP AND WATER.
ING EST: CONSULT HOSPITAL EMERGENCY ROOM ORPOISON CONTROL CENTER
IMMED.
* Fire Fighting Measures *
Extinguishing Media:NOT APPLICABLE. MEDIA SUITABLE FOR SURROUNDING FIRE
.
Fire Fighting Procedures:NONE. WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO
BUILDUP OF STEAM PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA TO PREVENT BUILDUP OF VAPORS.
FOR SMALL SPILLS, SOAK UP WITH ABSORBANT. FOR LARGE SPILLS, DIKE
AREA WITH ABSORBENT MATERIAL AND SCOOP UP LIQUIDS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE UPRIGHT IN SEALED CONTAINERS
AWAY FROM HEAT AND FLAME.
Other Precautions:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:SEE INGRED
Vapor Density:<AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING.
* Disposal Considerations *
Waste Disposal Methods:DISCARD IN LANDFILL IN SEALED-METAL CONTAINERS
AWAY FROM HEAT AND FLAME AND IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NORMALLY NOT REQUERED;USE NIOSH/MSHA APPROVED
RESPIRATOR AS REQUIRED IF ABOVE PEL/TLV.
Ventilation:ADEQUATE ROOM VENTILATION.
Other Protective Equipment:EYE WASH STATION,WORK CLOTHING AND APRON AS
REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
* Product Identification *
CAGE:0MMJ1
CAGE:0MMJ1
* Composition/Information on Ingredients *
Ingred Name:CHLOROTRIFLUOROETHYLENE TELOMER
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:PRACTIALLY NON TOXIC,MAY CAUSE
MILD EYES AND SKIN IRRITATION.CHROMIC:NO DATA AVAILABLE.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:PER MANUFACTURES,THERE ARE NO KNOWN CONDITIONS
OR SYMPTOMS ARISING FROM OVEREXPOSURE THROUGH SKIN OR EYES
CONTACT,INHALATION OR INGESTION.
Medical Cond Aggravated by Exposure:NO DATA AVAILABLE
* First Aid Measures *
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:USE EXTINGUISHING METHOD SUITABLE FOR SURROUNDINGS.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;CONTAIN FREE
MATERIAL IF POSSIBLE;USE SUITABLE INERT ABSORBENT MATERIAL AND
RECOVER FOR PROPER DISPOSAL IN AN APPROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY,VENTILATED AREA.DO
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
HCC:V6
Spec Gravity:2.0(CALCULATED)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS OIL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
METALS SUCH AS SODIUM,POTASSIUM & REDUCING AGENTS,AMINES,LIQUID
FLUORINE & LIQUID CHLORINE TRIFLUORIDE.
Stability Condition to Avoid:HEAT,IGNITION SOURCES
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY EMIT
CHLORINE, FLUORINE, HCL & HF GASES.
* Disposal Considerations *
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES.DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED FULL FACEPIECE
CHEMICAL CARTRIDGE RESPIRATOR OR A SUPPLIED AIR FULL FACEPIECE
RESPIRATOR OR AIRLINED HOOD.
Ventilation:A SYSTEM OF LOCAL EXHAUST IS RECOMMENDED TO KEEP EMPLOYEE
EXPOSURES BELOW THE TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
IMPERVIOUS BOOTS, APRON, OR COVERALLS AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS. PROTECT FROM MOISTURE.
* Product Identification *
Product ID:HYDROFLUORIC ACID
* Composition/Information on Ingredients *
Ingred Name:HYDROGEN FLUORIDE (SARA III)
Other REC Limits:NONE SPECIFIED
OSHA PEL:3 PPM/6 STEL (F)
Ingred Name:WATER
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CORROSIVE! INHALATION CAN CAUSE
COUGHING, CHOKING, & INFLAMATION OF THE RESPIRATORY TRACT.
SWALLOWING CAN CAUSE BURNS TO MOUTH & G.I. TRACT. EYE CONTACT CAN
CAUSE SEVERE BURNS & DAMAGE. SKIN CO NTACT CAN CAUSE SEVERE BURNS
AND DEEP ULCERS & DISCOLOR SKIN. CHRONIC: HYPOCALCEMIA,BONE AND
JOINT DAMAGE.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:SEVERE IRRITATION OF THE NOSE, THROAT, UPPER
RESPIRATORY TRACT, EYES, SKIN AND MUCOUS MEMBRANES. VERY CORROSIVE
AND CAN CAUSE SEVERE BURNS AND DAMAGE. LONG TERM EXPOSURES SELDOM
OCCUR DUE TO THE CORRO SIVE PROPERTIES OF THE ACID.TARGET ORGANS
EYES,SKIN AND RESPIRATORY SYSTEM.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
ATTENTION. S KIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND
WATER. GET IMMEDIATE MEDICAL ATTENTION. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER SPRAY GIVES MINIMUM HAZARD
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:MAY FORM EXPLOSIVE MIXTURE WITH AIR.DO
NOT USE A WATER STREAM.
* Accidental Release Measures *
Spill Release Procedures:SMALL SPILL: FLUSH WITH WATER AND NEUTRALIZE
WITH ALKALINE MATERIAL. SEWER NEUTRALIZED MATERIAL WITH EXCESS
WATER. LARGE SPILL: EVACUATE AND VENTILATE AREA. IF POSSIBLE, STOP
LEAK. DIKE TO RETAIN RUN OFF. NEUTRALIZE & PICK UP WITH ABSORBENT
MATERIAL.
Neutralizing Agent:SODA ASH, LIME OR OTHER SUITABLE ALKALINE MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:STORE ONLY IN APPROVED CONTAINERS,
AREA.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING. FOR
INDUSTRIAL USE ONLY.
* Physical/Chemical Properties *
HCC:C1
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS FUMING LIQ, SHARP, PENETRATING ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
FLUORINE, ARSENIC TRIOXIDE. PHOSPHOROUS PENTOXIDE, ALKALIES.
Stability Condition to Avoid:MOISTURE;WATER
Hazardous Decomposition Products:HYDROGEN,HYDROGEN FLUORIDE
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. DISPOSE
IN A RCRA-APPROVED WASTE FACILITY OR SEWER THE NEURTALIZED SLURRY
WITH EXCESS WATER IF LOCAL ORDINANCES ALLOW.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY NEEDED. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN.
Ventilation:LOCAL: PREFERRED. MECH(GENL): ACCEPTABLE.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:WASH CONTAMINATED CLTHG. DESTROY CONTAMD
LEATHER SHOES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Kit Part:Y
Preparer's Name:EDDIE PADILLA
CAGE:0WVC6
CAGE:0WVC6
* Composition/Information on Ingredients *
Ingred Name:BISPHENOL A-EPICHLOROHYDRIN COPOLYMER;(BISPHENOL A
DIGLYCIDYL)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALKYL GLYCIDYL ETHERS
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: NO REMARKABLE EFFECTS. INGEST:
MODERATELY TOXIC. SKIN: MODERATELY TOXIC. EYE: IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. INGEST: IF CONSCIOUS, GIVE LARGE
QTYS OF WATER. CALL MD. SKIN: WASH W/SOAP & WATER. EYE: FLUSH
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:CO*2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:ABSORB INTO SAND OR OTHER ABSORBENT MATERIAL.
SCOOP INTO CLOSABLE CONTAINER FOR DISPOSAL OF LARGE QUANTITIES.
CLEAN AREA WITH WATER OR APPROPRIATE SOLVENT.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:ADEQUATE VENTILATION; STORE IN CLOSED
CONTAINER IN A COOL, DRY AREA. WASH THOROUGHLY AFTER HNDLING.
Other Precautions:AVOID CONTACT WITH EYES, SKIN AND CLOTHING. AVOID
BREATHING OF VAPORS WHEN OPENING CONTAINER.
* Physical/Chemical Properties *
Evaporation Rate & Reference:1.0
Solubility in Water:INSOLUBLE
Appearance and Odor:LOW VISCOSITY LIQUID W/LITTLE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS; ACIDS.
Stability Condition to Avoid:LARGE QTYS OF RESIN/CURING AGENT MIX DUE
TO EXOTHERM.
Hazardous Decomposition Products:CO, CO*2 AND ALDEHYDES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:MFR STATES:NONE NEEDED.
Ventilation:LOCAL & GENERAL TO KEEP BELOW TLV.
Other Protective Equipment:AS NECESSARY TO PREVENT SKIN CONTACT.
Supplemental Safety and Health
PH = 3.5. CONTAINER: 1 GALLON.
* Product Identification *
Product ID:STABILIZER,PROCESSES E-3 & E-4.
* Composition/Information on Ingredients *
Ingred Name:FORMALDEHYDE (SARA III)
* Hazards Identification *
Effects of Overexposure:SKIN & EYE: LIQUID CAUSES IRRIT, MAY CAUSE
ALLERGIC SKIN REACTION. VAPOR IRRIT TO EYES & RESP TRACT.
* First Aid Measures *
INHAL: REMOVE FROM EXPOSURE.
* Fire Fighting Measures *
Lower Limits:7.0
Upper Limits:7.3
Extinguishing Media:WATER, CO*2, FOAM
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NOXIOUS ALDEHYDE FUMES.
* Accidental Release Measures *
Spill Release Procedures:NEUTRALIZE W/ SODIUM BISULFITE
*Handling and Storage *
Handling and Storage Precautions:OBSERVE PRECAUTIONARY MEASURES ON
CONTAINER. WASH THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
HCC:V4
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID,STRONG ALDEHYDE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:MFR RECOMMENDS: NEUTRALIZATION W/ SODIUM
BISULFITE THEN FLUSH TO SEWER W/ COPIOUS AMOUNTS OF WATER. DISPOSAL
METHOD MUST BE IAW FEDERAL, STATE & LOCAL CODES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHEN APPLYING IN ANY CIRCUMSTANCES LIKELY TO
PRODUCE AIRBORNE LEVEL OR HAZARDOUS INGREDIENTS IN EXCESS OF TLV,
USE AN ORGANIC VAPOR CARTRIDGE OR AIR-SUPPLIED RESPIRATOR.
Ventilation:GENERAL VENTILATION TO MAINTAIN VAPORS BELOW PEL.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:ERNEST CARTER
CAGE:0NYS9
CAGE:0NYS9
* Composition/Information on Ingredients *
Ingred Name:DIETHYLTOLUENEDIAMINE
Code:F
Ingred Name:TETRAKIS METHYLENE METHANOL
Code:F
< Wt:5.
* Hazards Identification *
Effects of Overexposure:EYE: IRRITANT.SKIN: TOXIC BY ABSORPTION. DERMAL
DUE TO LOW VOLATILITY OF DETDA AT ROOM TEMPERATURE.HOWEVER, HEATED
OR SPRAYED MATERIA L MAY GIVE OFF SIGNIFICANT AMOUNTS OF
VAPOR.INGESTION: TOXIC. CHRONIC EFFECTS IN THE PANCREAS, LIVER,
THYROID AND POSSIBLY THE ADRENAL GLANDS AND EYES.
* First Aid Measures *
PERSIST, CONSULT PHYSICIAN. SKIN: WASH WITH SOAP AND WATER.IF
SYMPTOMS PERSIST, CONSULT A PHYSICIAN.INHALATION: REMOVE TO FRESH
AIR.IF SYMPTOMS ARE PRESENT CONSULT A PHYSICIAN.INGESTION: GIVE
MILK OR WATER TO DRINK. INDUCE VOMITING. CONSULT A PHYSICIAN.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR.
* Accidental Release Measures *
Spill Release Procedures:WEAR AIR-SUPPLIED RESPIRATOR FOR MAJOR
UNVENTILATED SPILL.COVER WITH ABSORBENT. SCOOP INTO CONTAINERS.
CLEAN UP RESIDUE WITH A SUITABLE SOLVENT.
*Handling and Storage *
Handling and Storage Precautions:WASH THOROUGHLY AFTER HANDLING AND
BEFORE SMOKING OR EATING. AVOID INGESTION.
* Physical/Chemical Properties *
VOC Grams/Liter:8.5
Appearance and Odor:AMBER LIQUID
Percent Volatiles by Volume:0.0%
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:NOT A HAZARDOUS WASTE ACCORDING TO EPA
REGULATIONS. CONSULT STATE REGULATIONS PRIOR TO DISPOSAL OF
SPILLAGE.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-EXAM OF STOCK IN WHSE. SAFETY & HEALTH DATA DEVELOPED BY
DGSC-STF.
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
* Physical/Chemical Properties *
HCC:A2
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WITH ORGANIC
VAPOR CARTRIDGE OR SUPPLIED AIR RESPIRATOR IF EXPOSED ABOVE
PEL/TLV.
Ventilation:USE GENERAL OR LOCAL EXHAUST AS NEEDED TO REDUCE EXPOSURES
TO BELOW PEL/TLV.
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING AS NEEDED TO
PROTECT FROM SPLASHES AND PREVENT PROLONGED OR REPEATED SKIN
CONTACT.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. MINIMIZE
CONTACT WITH THE PRODUCT.
Supplemental Safety and Health
* Product Identification *
Product ID:ISOPROPYL ALCOHOL
* Composition/Information on Ingredients *
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS MILDLY IRRITATING AND
MODERATELY TOXIC. CHRONIC OVEREXPOSURE MAY CAUSE KIDNEY OR BRAIN
DAMAGE.
Effects of Overexposure:EYE:IRRITATION,TEARING,BLURRED VISION.
SKIN:PROLONGED/REPEATED:DRYING,DEFATTING,DERMATITIS.
INHALED:RESPIRATORY
IRRITATION,HEADACHE,DIZZINESS,FATIGUE,NAUSEA,POSSIBLE COMA.
INGESTED:G/I IRRITATION,NAUS EA,VOMITING,DIARRHEA.
Medical Cond Aggravated by Exposure:NONE REPORTED.
* First Aid Measures *
INHALED:REMOVE TO FRESH AIR. GIVE OXYGEN OR ARTIFICIAL RESPIRATION
IF NEEDED,AND IF SO,GET MEDICAL ATTENTION. INGESTION:DO NOT INDUCE
VOMITING . GIVE WATER AND GET IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:2.5
Extinguishing Media:DRY CHEMICAL,FOAM,CARBON DIOXIDE. WATER MAY BE
INEFFECTIVE BUT MAY BE USED TO DILUTE PRODUCT TO NON-FLAMMABILITY.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR. THEY MAY
TRAVEL TO LOW AREAS THEN FLASH-BACK FROM AN IGNITION SOURCE.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE AREA.
RECOVER AS LIQUID IF POSSIBLE,ADSORB ON INERT MATERIAL IF NOT.
STORE IN TIGHTLY CLOSED CONTAINERS (AS FLAMMABLE LIQUID) PENDING
DISPOSAL.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:STORE AS FLAMMABLE LIQUID; IN A WELL
VENTILATED AREA FREE FROM IGNITION SOURCES. OUTSIDE OR DETACHED
STORAGE IS SUGGESTED.
Other Precautions:GROUND CONTAINERS WHEN TRANSFERRING LIQUID. DO NOT
CUT,WELD,ETC.,ON "EMPTY" CONTAINERS,AS THEY MAY RETAIN EXPLOSIVE
QUANTITIES OF LIQUID OR VAPOR.
* Physical/Chemical Properties *
HCC:F2
Vapor Density:2.0
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR CLORLESS LIQUID,ALCOHOL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT,INGITION SOURCES
Hazardous Decomposition Products:NORMAL PRODUCTS OF COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
HMIS RECOMMENDS SOLVENT RECOVERY OR INCINERATION.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA-APPROVED RESPIRATOR WITH DUST
CARTRIDGE IF TLV IS EXCEEDED.
Ventilation:MECHANICAL (GENERAL) AND/OR LOCAL EXHAUST TO MAINTAIN
EXPOSURE LEVEL BELOW TLV.
Other Protective Equipment:USE MACHINE GUARDS AND PROTECTIVE CLOTHING
TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.DO NOT SHAKE
CLOTHING.REMOVE DUST BY WASHING OR VACUUMING.
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:JAY BEE
* Composition/Information on Ingredients *
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
Other REC Limits: SPECIFIED
OSHA PEL:SEE TABLE Z3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE EFFECTS:DUST MAY IRRITATE OR
INJURE EYES. CHRONIC EFFECTS:PNEUMOCONIOSIS.CARCINOGENIC BY IARC.
Explanation of Carcinogenicity:CRYSTALLINE SILICA IS CARCINOGENIC BY
IARC.
Effects of Overexposure:EYES:IRRITATION. SKIN:IRRITATION.
INHALATION:IRRITATION OF NOSE AND THROAT,NOSE BLEED,COUGH,SHORTNESS
OF BREATH,CHEST TIGHTNESS.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH A HISTORY OF
RESPIRATORY CONDITIONS MAY BE AT INCREASED RISK.
* First Aid Measures *
First Aid:EYES:FLUSH WITH PLENTY OF WATER.IF IRRITATION PERSISTS,SEE
DOCTOR. SKIN:REMOVE CONTAMINATED CLOTHING.WASH WITH SOAP AND
WATER.IF IRRITATION PERSISTS SEE DOCTOR. INHALATION:REMOVE TO FRESH
AIR.GIVE CPR /OXYGEN IF NEEDED. SEE DOCTOR. INGESTION:DRINK LARGE
AMOUNT OF WATER,INDUCE VOMIT.SEE DOCTOR.
* Fire Fighting Measures *
Extinguishing Media:AS APPROPIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:NO SPECIAL PROCEDURE.
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:VENTILATE.CLEAN UP USING METHODS THAT AVOID
DUST GENERATION SUCH AS VACUUM,WET DUST MOP OR WET CLEAN UP AND
PLACE IN APPROPIATE DISPOSAL CONTAINER AND COVER.IF DUST IS
GENERATED USE NIOSH/MSHA APPROVE D RESPIRATOR WITH DUST CARTRIDGE.
*Handling and Storage *
Handling and Storage Precautions: SPECIFIED BY MANUFACTURER.
Other Precautions:DO NOT BREATHE DUST. PERIODIC MEDICAL EXAMINATIONS
ARE RECOMMENDED FOR INDIVIDUALS REGULARLY EXPOSED TO DUST OR MIST.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:2.1-2.4
Solubility in Water:INSOLUBLE
Appearance and Odor:GREY SOLID REFRACTORY BRICK. NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:
Hazardous Decomposition Products: SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:NOTIFY YOUR LOCAL ENVIRONMENTAL OFFICER. KEEP IN
COVERED CONTAINERS PENDING DISPOSAL.DISPOSE OF IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE
Ventilation:USE LOCAL IF NECESSARY
Other Protective Equipment:NONE
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHYLPHENYLPOLISILOXANE
(TETRAMETHYLTETRAPHENYLTRISILOXANE)
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN:MILDLY IRRITATING.
MANUFACTURER STATES NOT ABSORBED THROUGH SKIN,AND NO DATA AVAILABLE
FOR INHALATION OR INGESTION.
Explanation of Carcinogenicity:NOT LISTED
Effects of Overexposure:SEE HEALTH HAZARDS
Medical Cond Aggravated by Exposure:NON NOTED
* First Aid Measures *
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR; IF BRTHNG
DIFF GIVE OXYGEN. EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP&WATER. RMV CONTAM CLTHG&SHOES. INGEST:INDUCE VOMIT. RPT
UNTIL VOMIT IS C LEAR. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATTN.
* Fire Fighting Measures *
Extinguishing Media:WATER FOG, FOAM, CO*2, DRY CHEM.
Fire Fighting Procedures:USE SCBA
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:ABSORB ON VERMICULITE AND SWEEP UP INTO A
STEEL DRUM
*Handling and Storage *
Handling and Storage Precautions:STORE AT ROOM TEMP IN TIGHTLY CLOSED
CONTAINERS. KEEP DRY. AVOID CONTACT W/SKN-EYES.
* Physical/Chemical Properties *
HCC:V6
Solubility in Water:NEG
Appearance and Odor:ODORLESS, CLEAR TO PALE YELLOW LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALI
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:OXIDES OF CARBON & SILICON.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW FEDERAL,STATE AND LOCAL
REGULATIONS
| 1 | gloves_mandatory |
Control Measures
*
Cage: 0Y5K6
*
Contractor Summary
*
Cage: 0Y5K6
*
Item Description Information
*
*
Ingredients
*
------------------------------
------------------------------
ACGIH STEL: NOT ESTABLISHED
------------------------------
< Wt: 2.
OSHA PEL: 1 MG/M3
ACGIH TLV: 1 MG/M3
ACGIH STEL: 3 MG/M3
------------------------------
ACGIH STEL: NOT ESTABLISHED
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Effects of Exposure: MAY CAUSE LIVER OR KIDNEY DAMAGE.REPEATED OR PROLONGED
SOLVENT OVEREXPOSURE MAY CAUSE PERMANENT CENTRAL NERVOUS SYSTEM DAMAGE.
CHRONIC SKIN CONTACT MAY CAUSE DERMATITIS.
Signs And Symptions Of Overexposure: EYE CONTACT: MAY CAUSE EYE IRRITATION.
SKIN CONTACT: MAY CAUSE SKIN IRRITATION. INHALATION: POSSIBLE IRRITATION OF
THE RESPIRATORY SYSTEM CAN OCCUR CAUSING A VARIETY OF SYMPTOMS SUCH AS
DRYNESS OF TH E THROAT, TIGHTNESS OF THE CHEST, AND SHORTNESS OF BREATH.
INGESTION: HARMFUL IF SWALLOWED.
First Aid: EYE CONTACT: FLUSH EYES IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR
ATTENTION. SKIN CONTACT: FLUSH SKIN WITH LARGE AMOUNTS O F WATER. GET MEDICAL
ATTENTION. INHALATION: MOVE PERSON TO FRESH AIR. RESTORE AND SUPPORT
CONTINUED BREATHING. GET IMMEDIATE MEDICAL ATTENTION. INGESTION: IF
SWALLOWED, DO NOT INDUCE VOMITING. GIVE V ICTIM ONE OR TWO GLASSES OF WATER
OR MILK. CALL A PHYSICIAN.
*
Handling and Disposal
*
Spill Release Procedures: AVOID BREATHING VAPORS. USE SELF CONTAINED BREATHING
EUIPMENT. CONTAIN AND REMOVE WITH INERT ABSORBENT MATERIAL AND NONSPARKING
TOOLS. AVOID CONTACT. REMOVE ALL SOURCES OF IGNITION.
Handling And Storage Precautions: AVOID SKIN AND EYE CONTACT. WASH THOROUGHLY
AFTER HANDLING. AVOID BREATHING OF VAPOR OR MISTS. DO NOT HANDLE UNTIL ALL
SAFETY PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. STORE ONLY IN WELL
VENTILATED AREAS. KEEP CONTAINER CLOSED WHEN NOT IN USE.
*
Fire and Explosion Hazard Information
*
Flash Point Method: SCC
Lower Limits: 1.3%
Extinguishing Media: CO2 DRY CHEMICAL FOAM FOG.
Fire Fighting Procedures: WEAR FULL FIREFIGHTING PROTECTIVE CLOTHING, INCLUDING
SELF CONTAINED BREATHING APPARATUS(SCBA).
Unusual Fire/Explosion Hazard: FLAMMABLE LIQUID AND VAPOR. KEEP CONTAINERS
TIGHTLY CLOSED. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN FLAME,
OTHER SOURCES OF IGNITION. CLOSED CONTAINER MAY RUPTURE WHEN EXPOSED TO
EXTREME HEAT.
*
*
Respiratory Protection: USE A NIOSH/MSHA APPROVED CHEMICAL/MECHANICAL FILTER
RESPIRATOR
Ventilation: SUFFICIENT VENTILATION IN PATTERN AND VOLUME SHOULD BE PROVIDED.
Other Protective Equipment: USE DISPOSABLE OR IMPERVIOUS CLOTHING IF WORK
CLOTHING CONTAMINATION IS LIKELY.
Work Hygienic Practices: WASH HANDS BEFORE EATING, SMOKING, ORUSING TOILET
FACILITY.
*
Physical/Chemical Properties
*
Vapor Density: HEAVIER
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: INSOLUBLE
Appearance and Odor: CLEAR LIQUID SOLVENT
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: HIGH TEMPERATURES. SOURCES OF IGNITION.
Materials To Avoid: STRONG ACIDS, BASES, AND STRONG OXIDIZERS.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR UNDER NORMAL CONDITIONS.
*
HAZCOM Label
*
Cage: 0Y5K6
Company Name: LORD CORPORATION, CHEMICAL PRODUCTS DIVISION
Label Required IND: Y
Status Code: A
Origination Code: G
Hazard And Precautions: MAY CAUSE LIVER OR KIDNEY DAMAGE. REPEATED OR
PROLONGED SOLVENT OVEREXPOSURE MAY CAUSE PERMANENT CENTRAL NERVOUS SYSTEM
DAMAGE. CHRONIC SKIN CONTACT MAY CAUSE DERMATITIS.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION TO
MAINTAIN EXPOSURE LEVELS.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO AVOID
SKIN CONTACT. AN EMERGENCY EYE WASH STATION AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
FAILURE TO OBSERVE CAUTIONS MAY RESULT IN EXCESSIVE HEAT BUILD-UP[ WITH
THE RELEASE OF TOXIC GASES.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:SILICA GEL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3 TDUST
Ingred Name:BORON TRIFLUORIDE (SARA III)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 1 PPM
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN RASH, SKIN IRRITATION.
MAY CAUSE SKIN AND LUNG IRRITATION AND POSSIBLE ALLERGIC REACTIONS.
PROLONGED AND REPEATED CONTACT MAY CAUSE SENSITIZATION WHICH WILL
RESULT IN ALLERGIC REACTIONS .
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:SKIN IRRITATION, SKIN RASH, LUNG IRRITATION,
ALLERGIC REACTIONS.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY AND/OR
SKIN DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION. IN HALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL
ATTENTION.
* Fire Fighting Measures *
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER FOG, DRY CHEMICAL, FOAM OR FOG
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:TOXIC GASES ARE RELEASED DURING
COMBUSTION.
* Accidental Release Measures *
Spill Release Procedures:SCRAPE UP AND TRANSFER TO METAL CONTAINER.
WIPE UP REMAINING RESIDUAL WITH SOLVENTS, OBSERVING SOLVENT
FLAMMABILITY CAUTIONS, OR USE DETERGENT.ORB LIQUID WITH SUITABLE
ABSORBENT MATERIAL. COLLECT FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES.
Other Precautions:FOLLOW RECOMMENDED CURING SCHEDULE.
* Physical/Chemical Properties *
HCC:N1
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:1.1
Evaporation Rate & Reference:< 1 REFERENCE NOT GIVEN
Solubility in Water:SLIGHT
Appearance and Odor:BLACK PASTE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, ALDEHYDES, ACIDS AND UNDETERMINED ORGANICS.
Conditions to Avoid Polymerization:AVOID MIXING RESIN AND CURING AGENT
IN BATCHES GREATER ATHA 1 POUND TOTAL. DO NOT HEAT MATERIAL UNLESS
CURING.
* Disposal Considerations *
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:OUTDOOR/OPEN AREAS,USE BUR OF UINES APPRVD MECH
FILTER RESPIRAT.
Ventilation:GEN.DILUTION OR LOC EXHAUST VENTILAT IN VOL TO KEEP TLV
ACCE
Other Protective Equipment:PRVNT PROLNG SKIN CONTCT TO CONTAMINAT
CLOTHING.
Supplemental Safety and Health
OTHER PRECAUT:DO NOT TAKE INTERNALLY.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ISOBUTYL ACETATE
Ingred Name:ISOBUTYL ALCOHOL (SARA III)
Fraction by Wt: <5%
Ingred Name:PHOSPHORIC ACID (SARA III)
Fraction by Wt: <0.5%
OSHA PEL:1 MG/M3/3 STEL
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TOLUENE (SARA III)
* Hazards Identification *
Effects of Overexposure:INHAL:ANESTH,IRRIT. OF RESPIR TRACT/ACUT NERV
SYS DEPRESSION,HDACH,DIZZ,CONFUS,UNCONSCIOUS,OR COMA.
* First Aid Measures *
First Aid:IN CASE OF CONTACT;FLUSH SKIN & EYES W/PLENTY OF WATER WHILE
REMOVING CONTAMINAT CLOTHING. IF INHALED, REMOVE TO FRESH AIR. CALL
A DR IF SYMPTOMS PERSIST.
* Fire Fighting Measures *
Extinguishing Media:CO*2,DRY CHEM OR ALCOH FOAM-SM FIRES;POLYMER
FOAM-LG FIRES
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS.WATR TO
COOL CLOS CONTNR.
Unusual Fire/Explosion Hazard:KP CONTNR TIGHTLY CLOSED.ISOLATE FR
HEAT,ELECT EQPMT,SPARKS
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT (FLAMES,HOT
SURFACES,& ELECT,STATIC OR FRICTIONAL SPARKS).AVOID BREATHING
VAPORS.VENTILAT AREA.REMOVE W/INERT ABSORBENT & NON-SPARKING TOOLS.
*Handling and Storage *
Other Precautions:CONTNRS SHLD BE GROUNDED WHEN POURING.AVD FREE FALL
OF LIQD IN EXCES OF FEW INCHES.DO NOT FLAME CUT,BRAZE OR WELD
COATED MATER W/O BUR OF MINES APPRVD RESPIROR APPROP VENT.ADD LABEL
WARN(SUP)
* Physical/Chemical Properties *
HCC:F2
Vapor Density:HEAV
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AVOID HEAT,FIRES,& HOT SURFACES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORD W/LOCAL, STATE & FEDERAL
REGULATIONS.INCINERATE IN APPRVD FACILITY.DO NOT INCINERATE CLOSED
CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:GENERAL VENTILATION.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
Preparer's Name:AS
* Composition/Information on Ingredients *
Ingred Name:MAGNESIUM CHROMATE
Other REC Limits:NONE SPECIFIED
OSHA PEL:STEL 0.1 PPM (CEIL)
Ingred Name:MANGANESE DIOXIDE (EXPOSURE LIMITS ARE BASED ON AIRBORNE
PARTICLES. MAT'L FULLY ENCAPSULATED, NO AIRBORNE PARTICLES)
Other REC Limits:NONE SPECIFIED
OSHA PEL:STEL 5 MG/M3 CEILING
ACGIH TLV:5 MG/M3
Ingred Name:1,3-DIPHENYL GUANIDINE (DPG)
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Ingred Name:HYDROGENATED TERPHENYLS
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 PPM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: STRONG IRRIT, DAMAGE. SKIN:
IRRIT. ALLERGIC SKIN RASH. PROLONGED EXPOSURE OVER PEL MAY CAUSE
PAINLESS PENETRATING SKIN ULCERS. INHAL & INGEST: MAIN HAZARD FROM
DUST. MANGANESE POISONING (WEAK,SL EEPY). PROLONGED EXPOSURE MAY
CAUSE PENETRATING NOSE MUCOUS MEMBRANES ULCERS & PERFORATION OF
CARTILAGINOUS NASAL SEPTUM
* First Aid Measures *
PERSIST, CONSULT PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. IF
SYMPTOMS PERSIST, CONSULT A PHYSICIAN. INHALATION: REMOVE TO FRESH
AIR. IF SY MPTOMS ARE PRESENT CONSULT A PHYSICIAN.INGESTION:
CONSULT A PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:SCC
Flash Point:NOT FLAMMABLE
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR. USE WATER TO COOL
HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:EXCESSIVE HEAT MAY CAUSE DECOMPOSITION OF
MANGANESE DIOXIDE, RESULTING IN OXIDATION AND POSSIBLE IGNITION OF
HYDROCARBON VEHICLE.
* Accidental Release Measures *
Spill Release Procedures:SCOOP INTO CONTAINERS. CLEAN-UP RESIDUE WITH
1,1,1-TRICHLOROETHANE.
*Handling and Storage *
Handling and Storage Precautions:WASH THOROUGHLY AFTER HANDLING AND
BEFORE EATING. AVOID INGESTION.
Other Precautions:THIS PRODUCT CONTAINS A TOXIC CHEMICAL OR CHEMICALS
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK LIQUID
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
EASILY OXIDIZABLE MATERIALS.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN,
MANGANESE COMPOUNDS.
* Disposal Considerations *
COMPLIANCE WITH FEDERAL AND STATE REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:MSHA/NIOSH APROVED RESPIRATOR FOR PARTICULAR
EXPOSURE OF CONCERN
Ventilation:KEEP CONCETRATION BELOW TLV
Other Protective Equipment:ARON, BARRIER CREAM
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:LINSEED OIL
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
Fraction by Wt: 8%
* Hazards Identification *
Effects of Overexposure:DRYING OF SKIN/EYE IRRIT.EXCSSV
INHAL:ANESTHSIA,HDACHE,DIZZ,NAUSEA,UPPER RESPIRATORY IRRITATION.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR, APPLY ART RESP IF NEC. CALMD.
SKIN:WAS W/MILD SOAP&WATER, APPLY A MILD CREAM. IN SEVERE CASES CAL
CALL MD .
* Fire Fighting Measures *
Lower Limits:0.9
Upper Limits:6.0
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER SPRAY
Fire Fighting Procedures:USE SELF-CONTND BRTHNG APPRTUS. WATER INEFF
EXCEPT FOR COOLN
* Accidental Release Measures *
Spill Release Procedures:FLUSH W/WATER INTO RETAINING AREA OR
CONTAINER.AVOID SPARKS,FIRE,OR HOT METAL SURFACES. SMALL QUANTITIES
MAY BE ABSORBED ONTO APROPRIATE ABSORBENT.DISPOSE DRY WASTE IN
DISPOSAL CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:KEEP COOL & AWAY FROM SOURCES OF
IGNITION. USE W/ADEQUATE VETILATON.AVOID PROLONGED/REPEATED SKIN
CONTACT.
Other Precautions:PERIODIC BLOOD TESTS RECOMMENDED(LEAD).WASH HANDS
THOROUGHLY BEFORE EATING.WASH THOROUGHLY ALL EXPOSED AREAS AFTER
HANDLING. GOOD PERSONAL HYGIENE.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:2
Vapor Density:4.9
Evaporation Rate & Reference:0.1 N-BU. ACETATE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:MEDIUM CHROME GREEN
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME,FIRE-
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CO &
CO*2
* Disposal Considerations *
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS OR DISPOSE IN
ACCORDANCE W/LOCAL,STATE & FEDERAL CODES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH/MSHA APPROVED SCBA
Ventilation:MECHANICAL (GEN) RECOMMENDED
Other Protective Equipment:COVERALLS AND BOOTS
Supplemental Safety and Health
MSDS UNDATED
* Product Identification *
Product ID:INHIBITOR,ICING FUEL SYSTEM
* Composition/Information on Ingredients *
Ingred Name:2-METHOXYETHANOL (EGME) (SARA III)
Ingred Name:2,6 DITERTIARY BUTYL,4-METHYLPHENOL;OR 2,4
DIMETHYL,6-TERTIARY BUTYLPHENOL; OR
Ingred Name:2,6 DITERTIARY BUTYLPHENOL; OR MIXED TERTIARY BUTYLPHENOL
COMPOSITION)
PERMITTED BY SPEC.
* Hazards Identification *
Effects of Overexposure:HEAD,NAU,VOMIT,FTG, GI DIST.
* First Aid Measures *
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR; IF BRTHNG
DIFF GIVE OXYGEN. EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP&WATER. RMV CONTAM CLTHG&SHOES. INGEST:INDUCE VOMIT. RPT
UNTIL VOMIT IS C LEAR. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATTN.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY,DRY CHEM,ALCOHOL FOAM,CO*2
Fire Fighting Procedures:WEAR NIOSH/MSHA SCBA WHEN FIGHTING FIRE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
PLACE IN SEALED DISPOSAL DRUM. FLUSH RESIDUE W/WATER. WASH CONTAM
CLTHG BEFORE REUSE.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT. DO NOT TAKE INTERNALLY.
AVOID BREATHING MIST OR VAPOR. STORE IN COOL, WELL VENT AREA AWAY
FM SOURCES OF IGNITION.
Other Precautions:NONE.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:6
Vapor Density:2.6
Solubility in Water:APPRECIABLE
Appearance and Odor:CLEAR COLORLESS LIQUID, MILD ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MFG.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE SPECIFIED BY MFG.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE I/A/W ALL LOCAL,STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
Control Measures
*
Cage: HANNA
*
Contractor Summary
*
Cage: HANNA
*
Ingredients
*
% Wt: <0.5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
% Wt: <0.5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE REPORTED.
First Aid: INGEST: CALL MD IMMEDIATELY (FP N). INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) (FP N). EYES: FLUSH
THOROUGHLY WITH RUNNING WATER. GET MEDICAL HELP IF IRRITATION PERSISTS.
SKIN: WASH EXPOSED AREA WITHSOAP AND WATER. GET MEDICAL HELP IF IRRITATION
PERSISTS.
*
Handling and Disposal
*
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND
LOCAL REGULATIONS.
Handling And Storage Precautions: STORAGE PRECAUTIONS: NONE.
Other Precautions: AVOID CONTACT WITH EYES, SKIN AND CLOTHING. WASH THOROUGHLY
AFTER HANDLING.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: WATER, CARBON DIOXIDE, FOAM OR DRY CHEMICAL.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
*
*
Respiratory Protection: USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: ADEQUATE VENTILATION.
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
*
Physical/Chemical Properties
*
Spec Gravity: 1.0
Appearance and Odor: SLIGHTLY SOAPY LIQUID; NO ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE.
Materials To Avoid: NONE.
Hazardous Decomposition Products: NONE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Cage: HANNA
Company Name: HANNA INSTRUMENTS INC
Label Required IND: Y
Status Code: C
Origination
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: MAY IRRITATE SKIN AND EYES, RESPIRATORY TRACT.
CHRONIC: NONE LISTED BY MANUFACTURER.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY REQUIRED. IF TLV IS EXCEEDED USE
NIOSH/MSHA APPROVED ORGANIC VAPOR & MIST, SUPPLIED AIR RESPIRATOR
OR SCBA.
Ventilation:USE ADEQUATE MECHANICAL (GENERAL &/OR LOCAL) VENTILATION TO
MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING. EYEWASH STATION.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING RESTROOMS.
REMOVE & WASH ALL CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
CAGE:SMILA
CAGE:SMILA
* Composition/Information on Ingredients *
Fraction by Wt: 2%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Fraction by Wt: 7%
Ingred Name:ZINC OXIDE
Fraction by Wt: 9%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY CAUSE IRRIT TO SKIN, EYES &
INTESTINAL SYSTEM. INHAL:ADVERSE HLTH EFTS FROM VAPS/SPRAY MISTS IN
POORLY VENTED AREAS MAY INCLUDE IRRIT OF MUC MEMBS OF NOSE, THROAT
& RESP TRACT & SYMPS OF HDC H & NAUS. EYES:IN DIRECT CONTACT, MAY
CAUSE IRRIT. SKIN:PRLNG & RPTD CONTACT W/PRODUCT MAY CAUSE
IRRIT.(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:REDNESS, DRYING OF SKIN/OTHER SIGNS OF
IRRIT/CONTACT DERM. INGEST:CAN CAUSE GI IRRIT, NAUS, VOMIT & DIARR.
CHRONIC:PRLNG/RPTD EXPOS ABOVE TLV MAY RESULT IN PERM BRAIN & NERV
SYS DMG.
Medical Cond Aggravated by Exposure:NONE KNOWN
* First Aid Measures *
SKIN:WASH AFFECTED AREAS W/SOAP & WATER. REMOVE CONTAM CLTHG. IF
IRRIT PERSISTS, CALL MD. INHAL:REMOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY , CALL MD. INGEST:DRINK 1 OR 2 GLASSES OF WATER TO
DILUTE. DO NOT INDUCE VOMIT. CALL MD/POIS CTL CTR IMMED. TREAT
SYMPTOMATICALLY.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:3.2%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . COOL CONTAINERS W/WATER SPRAY.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO HIGH
TEMPERATURES MAY EXPLODE OR BURST DUE TO BUILD UP OF STEAM
PRESSURE.
* Accidental Release Measures *
Spill Release Procedures:DIKE, CONTAIN OR ABSORB W/INERT MATERIALS.
TRANSFER TO CONTAINERS FOR RECOVERY OR DISPOSAL. PREVENT RUNOFF
INTO SEWERS, STREAMS OR OTHER BODIES OF WATER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:DO NOT EXPOSE TO EXTREMES IN
TEMPERATURE. AVOID EXPOSURE TO HIGH TEMPERATURES. DO NOT ALLOW TO
FREEZE.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PROLONGED OR REPEATED
EXPOSURE TO LEVELS ABOVE TLV. KEEP OUT OF REACH OF CHILDREN.
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:SEE ING 1
Vapor Density:LTR/AIR
Spec Gravity:1.3 (H2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:COMPLETE
Appearance and Odor:TYPICAL FOR WATER BASED PAINTS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:MAY FORM TOXIC MATLS, CO2, CO, VARIOUS
HYDROCARBONS, ETC, ON THERMAL DECOMPOSITION.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W ALL LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:PROPER RESPIRATOR SELECTION SHOULD BE DETERMINED
BY ADEQUATELY TRAINED PERSONNEL, BASED ON THE CONTAMINANTS, THE
DEGREE OF POTENTIAL EXPOSURE AND PUBLISHED RESPIRATORY PROTECTION
FACTORS. THIS SHOULD BE AVAILABLE FOR ROUTINE AND NONROUTINE
Ventilation:USE IN WELL VENTILATED AREA. IN CONFINED SPACE, MECHANICAL
VENTILATION MAY BE NECESSARY TO KEEP BELOW PEL/TLVS
Other Protective Equipment:IMPERVIOUS CLOTHING/BOOTS, EMERGENCY
EYEWASH/SHOWER. NOTTE: DO NOT CONTACT LENSES WHEN WORKING AROUND
THIS PRODUCT.
Work Hygienic Practices:LEATHER GOODS CONTAMINATED WITH THIS PRODUCT
SHOULD BE DISCARDED. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
VAPORS MAY ACCUMULATE IN LOW AREAS. VAPORS MAY CONCENTRATE IN CONFINED
AREAS. USE ADEQUATE GROUNDING TO PREVENT STATIC BUILDUP. RUNOFF TO
SEWER MAY CAUSE FIRE OR EXPLOSION HAZARD. CONTAMINATED CLOTHIN G,
RAGS OR SIMILAR ORGANIC MATERIAL STORED IN CLOSED SPACE MAY
SPONTANEOUSLY IGNITE.
* Product Identification *
Product ID:CRUDE OIL
Preparer's Name:SUE BOTTOM
* Composition/Information on Ingredients *
Ingred Name:BENZENE (SARA III)
Fraction by Wt: 0.1-5%
Other REC Limits:NONE SPECIFIED
Ingred Name:BUTANE
Fraction by Wt: 1-7% %
Other REC Limits:NONE SPECIFIED
Ingred Name:CYCLOHEXANE (SARA III)
Fraction by Wt: <1-4% %
Other REC Limits:NONE SPECIFIED
Ingred Name:CYCLOPENTANE
Fraction by Wt: <1-2% %
Other REC Limits:NONE SPECIFIED
Ingred Name:ETHYL BENZENE (SARA III)
Fraction by Wt: <1-3%
Other REC Limits:NONE SPECIFIED
Ingred Name:N-HEPTANE
Fraction by Wt: 1-5% %
Other REC Limits:NONE SPECIFIED
Ingred Name:HEXANE (N-HEXANE)
Fraction by Wt: 2-8% %
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:HYDROGEN SULFIDE (SARA III)
Fraction by Wt: <0.1-3%
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYLCYCLOHEXANE
Fraction by Wt: 1-4% %
Other REC Limits:NONE SPECIFIED
Ingred Name:NONANE
Fraction by Wt: 1-4% %
Other REC Limits:NONE SPECIFIED
Ingred Name:OCTANE
Fraction by Wt: 1-5% %
Other REC Limits:NONE SPECIFIED
Ingred Name:PENTANE
Fraction by Wt: 1-6% %
Other REC Limits:NONE SPECIFIED
Ingred Name:PROPANE
Fraction by Wt: 1-4% %
Other REC Limits:NONE SPECIFIED
Ingred Name:SULFUR
Fraction by Wt: <0.1-3%
Other REC Limits:NONE SPECIFIED
Ingred Name:TOLUENE (SARA III)
Fraction by Wt: <1-2% %
Other REC Limits:NONE SPECIFIED
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Fraction by Wt: <1-3% %
Other REC Limits:NONE SPECIFIED
Ingred Name:HEXANE (ISOMERS OTHER THAN N-HEXANE)
Fraction by Wt: 1-5% %
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:MAY CAUSE SEVERE EYE IRRITATION,
CONJUNCTIVITIS, MAY CAUSE MODERATE SKIN IRRITATION, DEFATTING,
DERMATITIS, NASAL AND RESPIRATORY TRACT IRRITATION, CENTRAL NERVOUS
SYSTEM EFFECTS, POSSIBLE SECONDARY I NFECTION, ANEMIA, IRREGULAR
HEART RHYTHM, BEHAVIORAL CHANGES, HARMFUL OR FATAL IF SWALLOWED,
GASTROINTESTINAL DISTURBANE
Explanation of Carcinogenicity:BENZENE, A COMPONENT OF CRUDE OIL, IS
LISTED AS A CARCINOGEN BY NTP, IARC AND OSHA.
Effects of Overexposure:EYE IRRITATION, REDNESS, TEARING, BLURRED
VISION, SKIN IRRITATION, CRACKING, REDNESS, ITCHING, INFLAMMATION,
EXCITATION, EUPHORIA, CONTRACTED EYE PUPILS, DIZZINESS, DROWSINESS,
FATIGUE, NAUSEA, HEADAC HE, LOSS OF REFLEXES, TREMORS, CONVULSIONS,
SEIZURES, LOSS OF CONSCIOUSNESS, COMA, DEPRESSION, DIARRHEA,
VOMITING.
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN, HEART,
CENTRAL NERVOUS SYSTEM AND RESPIRATORY DISORDERS MAY BE AGGRAVATED
BY EXPOSURE TO THIS PRODUCT. IMPAIRED KIDNEY, LIVER AND BLOOD
DISORDERS MAY BE AGGRAVATED.
* First Aid Measures *
First Aid:EYES: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR AT
WATER. REMOVE CONTAMINATED CLOTHING PROMPTLY. HIGH PRESSURE SKIN
INJECTION S ARE SERIOUS MEDICAL EMERGENCIES! GET IMMEDIATE MEDICAL
ATTENTION. INHALATION: REMOVE TO FRESH AIR. TREAT SYMPTOMATICALLY.
INGESTION: DO NOT INDUCE VOMITING. GIVE VEGETABLE OIL. GET MEDICAL
ATTENTION
* Fire Fighting Measures *
Lower Limits:0.4 %
Extinguishing Media:DRY CHEMICAL, HALON, FOAM AND CARBON DIOXIDE ARE
PREFERRED. FOAM AND WATER FOG CAN CAUSE FROTHING.
Fire Fighting Procedures:PRODUCT WILL RELEASE FLAMMABLE VAPORS WHICH
CAN BURN IN OPEN OR BE EXPLOSIVE IN CONFINED SPACE. PUMP CONTENTS
FROM TANK AND COOL TANKS WITH WATER.
Unusual Fire/Explosion Hazard:IMPROPER USE OF WATER MAY CAUSE FROTHING
AND SPREAD FIRE OVER LARGER AREA. VAPOR OR GAS MAY SPREAD TO
DISTANT IGNITION SOURCES AND FLASH BACK.
* Accidental Release Measures *
Spill Release Procedures:STAY UPWIND AND AWAY FROM SPILL. DO NOT ENTER
OR STAY IN AREA UNLESS MONITORING INDICATES OK. ISOLATE HAZARD
AREA; RESTRICT ENTRY. RECOVER AS MUCH AS POSSIBLE. THEN ABSORB AND
HANDLE IAW ENVIRONMENTAL REGULATIONS. KEEP OUT OF
SEWERS/WATERWAYS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARK AND FLAMES.
DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL ON OR NEAR THIS
CONTAINER. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:SPECIAL H2S WARNING: CARE MUST BE TAKEN BY THOSE WHO
ARE RENDERING AID TO THE VICTIM BECAUSE H2S MAY BE IN AREA AND MAY
ALSO OVERCOME RESCUERS UNLESS IT HAS BEEN DETERMINED THAT THE AREA
IS FREE OF HY DROGEN SULFIDE.
* Physical/Chemical Properties *
HCC:F4
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Density:> 1
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:SLIGHT
Appearance and Odor:DARK BROWN/BLACK LIQUID WITH HYDROCARBON/SULFIDE
ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS (PEROXIDE, DICHROMATE, PERMANGANATE,
CHLORINE, ETC), STRONG ACIDS, CAUSTICS AND HALOGENS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, STATIC
ELECTRICITY OR OTHER POTENTIAL IGNITION SOURCES SHOULD BE AVOIDED.
DO NOT SWITCH LOAD.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
REACTIVE HYDROCARBONS (ALDEHYDES, AROMATICS, ETC) COMPOUNDS
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF MATERIAL IN ACCORDANCE WITH LOCAL,
COUNTY, STATE AND FEDRAL REGULATIONS. CONTACT STATE AND FEDERAL
REGULATORS TO DETERMINE WASTE CLASSIFICATION. USE LICENSED
TRANSPORTER AND DISPOSAL FACILI TY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AIRBORNE CONC SHLD BE KEPT TO LOWEST LVLS POSS.
IF VAP/MIST/DUST IS GENERATED, USE NIOSH/MSHA APPRVED RESP AS
APPROP. SUPPLIED AIR RESP PROT SHOULD BE USED FOR CLEANING LARGE
SPILLS/UPON ENTRY INTO TA NKS, VESSELS, OTHER CONFINED SPACES.
Ventilation:ADEQUATE TO MEET COMPONENT OCCUPATIONAL EXPOSURE LIMTS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH EXPOS SKIN SEVERAL TIMES DAILY W/SOAP &
WATER. SOILED WORK CLTHG SHLD BE LAUNDER/DRY CLEAN AT LEAST
ONCE(SUPP DATA)
Supplemental Safety and Health
FIRE FIGHT PROC: VAP & TO PROVIDE PROT FOR PERS ATTEMPTING TO STOP
LEAK. FIRST AID PROC: BECOMES DFCLT/SYMPS PERSIST. WASTE DISP METH:
THIS IS BECAUSE PROD USES, TRANSFORMATION, MIXING, PROCESS, ETC,
MAY RENDER RSLTG MATLS HAZ. HYGIENE PRAC: A WEEK. REMOVE/LAUNDER
CONTAMD CLTHG BEFORE REUSE. DRY (ING 2)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:LUBRICANT; (LUBRICANT CONTAINING PHTHALATE & ADIPATE
DIESTERS, SYNTHETIC HYDROCARBON)
ACGIH TLV:5 MG/M3 MIST (MFR)
Ingred Name:SUPP DATA: CLEANING CONTAMD CLTHG MAY BE MORE EFTIVE THAN
NORMAL LAUNDERING. INFORM INDIVIDUALS RESPONSIBLE FOR (ING 3)
Ingred Name:ING 2: FOR CLEANING OF POTENTIAL HAZARDS ASSOCIATED WITH
HANDLING CONTAMINATED CLOTHING.
Ingred Name:OTHER PRECS: EXPOSE TO OPEN FLAME OR HEAT. KEEP CNTNRS
CLOSED & DRUM BUNGS IN PLACE.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MAY CAUSE MINIMAL IRRIT,
EXPERIENCED AS TEMP DISCOMFORT. SKIN: NO ADVERSE EFTS EXPECTED FORM
ABSORP OF MATL THRU SKIN. BRIEF CONTACT IS NOT IRRIT. PRLNG
CONTACT, AS W/CLTHG WETTED W/MATL,MAY CAUSE DEFATTING OF
SKIN/IRRIT, SEEN AS LOCAL REDNESS W/POSS MILD DISCOMFORT. INHAL:
VAPS/MISTS, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: IN EXCESS OF PERMISSIBLE CONCS/IN
UNUSUALLY HIGH CONCS GENERATED FROM SPRAYING, HEATING MATL/AS FROM
EXPOS IN POORLY VENT AREAS/CONFINED SPACES, MAY CAUSE IRRIT OF
NOSE, THROAT, HEADACHE, NA USEA & DROWS. INGEST: IF >SEVERAL
MOUTHFULS INGESTED, ABDOM DISCOMFORT, NAUSEA, DIARRHEA MAY OCCUR.
Medical Cond Aggravated by Exposure:BECAUSE OF ITS DEFATTING
PROPERTIES, PROLONGED AND REPEATED SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS (SKIN CONDITION).
* First Aid Measures *
MED ATTN IF EYE IRRIT PERSISTS. SKIN: WASH SKIN W/PLENTY OF SOAP &
WATER FOR SEVERAL MINUTES. GET MED ATTN IF SKIN IRRIT
DEVELOPS/PERSISTS.INGEST: IF MORE THAN SEVERAL MOUTHFULSHAVE BEEN
INGEST, GIVE 2 GLASSES OF WATER. GET MED ATTN. INHAL: IF IRRIT,
HDCH, NAUS, OR DROWS OCCURS, REMOVE TO FRESH AIR. GET MED ATTN IF
BRTHG (SUPP DATA)
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:ACCORDING TO NFPA GUIDE, USE WATER SPRAY, DRY
CHEMICAL, FOAM, CO*2. WATER/FOAM MAY CAUSE FROTHING.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. USE WATER TO COOL FIRE EXPOS CNTNRS. IF LEAK/SPILL HAS NOT IGNIT,
USE WATER SPRAY TO DISPERSE (SUPP DATA)
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:VENT AREA. AVOID BRTHG VAPOR. USE NIOSH/MSHA
APPRVD SCBA/SUPPLIED AIR FOR LGE SPILLS/CONFINED AREAS. CONTAIN
SPILL IF POSS. WIPE UP/ABSORB ON SUITABLE MATL & SHOVEL UP. PVNT
ENTRY INTO SEWERS & WATERW AYS. AVOID CONTACT W/SKIN, EYES OR
CLOTHING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:MIN FEASIBLE HNDLG TEMPS SHLD BE
MAINTAINED. PERIODS OF EXPOS TO HIGH TEMPS SHLD BE MINIMIZED. WATER
CONTAM SHOULD BE AVOIDED.
Other Precautions:AVOID PRLNGD BRTHG OF MIST/VAP. MISUSE OF EMPTY
CNTNRS CAN BE HAZ. EMPTY CNTNRS CAN BE HAZ IF USED TO STORE TOXIC,
FLAMM/REACTIVE MATLS. CUTTING/WELDING EMPTY CNTNRS MIGHT CAUSE
FIRE, EXPLOS, TOX FUME S FROM RESIDUES. DO NOT PRESS (ING 4)
* Physical/Chemical Properties *
HCC:V6
Vapor Pres:<5.0
Vapor Density:>1.0
Appearance and Odor:CLEAR LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC LEVELS OF CO, CO*2, IRRITATING
ALDEHYDES AND KETONES.
* Disposal Considerations *
Waste Disposal Methods:PROD HAS BEEN EVAL FOR RCRA CHARACT & DOES NOT
MEET CRITERIA OF HAZ WASTE IF DISCARDED IN ITS PURCHASED FORM.
UNDER RCRA, IT IS RESPONSIBILITY OF USER OF PROD TO DETERMINE AT
TIME OF DISP, WHETHER PRO D MEETS RCRA CRITERIA FOR HAZ WASTE.
(SUPP DATA)
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURE LIMITS ARE EXCEEDED, A NIOSH/MSHA
APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED IN ABSENCE OF PROPER
ENVIRONMENTAL CONTROL. A NIOSH/MSHA RESPIRATOR (NEGATIVE PRESSURE
MODE) UNDER SPECIFIED C ONDITIONS.
Ventilation:SUFFICIENT MECHANICAL (GENERAL/LOCAL EXHAUST) TO MAINTAIN
EXPOSURE BELOW TLV.
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS, CLEAN WATER FOR
FLUSHING EYES & SKIN.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING, SMOKING/USING THE WASHROOM.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:WAYNE MCELYEA
CAGE:DALWO
CAGE:DALWO
* Composition/Information on Ingredients *
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
ACGIH TLV:2 MG/CUM (RESP DUST)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF THE NOSE,
THROAT & SIGNS OF NERVOUS SYSTEM DEPRESSION. EYES: MILD IRRITATION.
SKIN: MILD IRRITATION/DERMATITIS. INGESTION: IRRITATION OF
DIGESTIVE TRACT & NERVOUS SYSTEM DEPR ESSION. THIS MATERIAL CAN
ENTER LUNGS DURING SWALLOWING/VOMITING & CAUSE LUNG INFLAMMATION &
DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DROWSINESS, DIZZINESS,
LOSS OF COORDINATION, FATIGUE, STINGING, TEARING, REDNESS, DRYING,
CRACKING, DEFATTING, VOMITING, INFLAMMATION, BREATHING DIFFICULTY,
BLURRED VISION, NAUSE A, DIARRHEA
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG DISORDERS, SKIN
DISORDERS
* First Aid Measures *
First Aid:EYES: MOVE TO FRESH AIR, FLUSH EYES W/CLEAN WATER. SKIN:
THOROUGHLY WASH W/MILD SOAP & WATER. INHALATION: MOVE INTO FRESH
AIR. IF NOT BREATHING, BEGIN CPR. INGESTION: DRINK 1-2 GLASSES OF
WATER TO DIL UTE. DON'T INDUCE VOMITING. TREAT SYMPTOMATICALLY.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WATER MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT PRESSURE BUILDUP & POSSIBLE AUTO-IGNITION/EXPLOSION. USE
SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TOXIC GASES MAY FORM WHEN PRODUCT BURNS.
CLOSED CONTAINERS MAY BURST IF EXPOSED TO EXTREME HEAT/FIRE.
* Accidental Release Measures *
Spill Release Procedures:ISOLATE AREA. PREVENT MATERIAL FROM ENTERING
SEWERS/STORM DRAINS. MAY BE ABSORBED INTO AN APPROPRIATE ABSORBENT
MATERIAL SUCH AS SAWDUST/RAGS.
*Handling and Storage *
Handling and Storage Precautions:KEEP CLOSURE TIGHT & CONTAINER UPRIGHT
TO PREVENT LEAKAGE. KEEP CONTAINER CLOSED. STORE ONLY IN APPROVED
CONTAINERS. PROTECT FROM PHYSICAL DAMAGE.
Other Precautions:DON'T GET IN EYES. AVOID SKIN CONTACT. AVOID
BREATHING SANDING DUST. PREVENT PROLONGED/REPEATED BREATHING OF
VAPOR/SPRAY MIST. DON'T HANDLE UNTIL SAFETY PRECAUTIONS HAVE BEEN
READ & UNDERSTOOD.
* Physical/Chemical Properties *
Vapor Density:<1
Spec Gravity:1.2
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:COMPLETE
Appearance and Odor:MILKY VISCOUS W/CHARACTERISTIC ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:HEAT, FIRE, ELEVATED TEMPS
Hazardous Decomposition Products:CO2, CO
* Disposal Considerations *
Waste Disposal Methods:DON'T INCINERATE SEALED CONTAINERS. DISPOSE OF
IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR. AIR-SUPPLIED
OR FILTERING TYPE WITH ORGANIC VAPOR CARTRIDGES ARE RECOMMENDED.
Ventilation:LOCAL AND MECHANICAL EXHAUST RECOMMENDED. AVOID OPEN
ELECTRICAL SOURCES NEAR PRODUCT VAPOR AREAS.
Other Protective Equipment:SAFETY SHOES, EYE WASH STATION & SAFETY
SHOWER.
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID SKIN CONTACT.
WASH SKIN AFTER USING PRODUCT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health
* Product Identification *
Product ID:ISOPROPYL ALCOHOL
* Composition/Information on Ingredients *
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: OVEREXPOSURE MAY LEAD TO
CENTRAL NERVOUS SYSTEM DEPRESSION, LEADING TO HEADACHES AND
DIZZINESS. EYE: MAY LEAD TO IRRITATION AND WILL INJURE EYE TISSUE
IF NOT REMOVED PROMPTLY. SKIN: MAY LEAD TODERMATITIS. INGESTION:
MAY LEAD TO VOMITING. CHRONIC: PROLONGED SKIN CONTACT MAY CAUSE
DERMATITIS.ISOPR. DAMAGES FETUS.
Explanation of Carcinogenicity:THIS CHEMICAL IS NOT LISTED AS HAVING
ANY EVIDENCE OF BEING CARCINOGENIC.
Effects of Overexposure:OVEREXPOSURE MAY LEAD TO DIZZINESS, HEADACHES,
DERMATITIS AND EYE IRRITATION. HIGH VAPOR CONCENTRATIONS ARE
ANESTHETIC AND MAY HAVE OTHER CENTRAL NERVOUS SYSTEM EFFECTS.
Medical Cond Aggravated by Exposure:PERSONS WITH SKIN, HEART,
RESPIRATORY, OR ANY OTHER MEDICAL CONDITION SHOULD USE CAUTION WHEN
HANDLING OR USING THIS PRODUCT.
* First Aid Measures *
First Aid:SKIN: IMMEDIATELY FLUSH WITH SOAP AND WATER. GET MEDICAL
ATTENTION IF NECESSARY. INHALATION: IMMEDIATELY REMOVE VICTIUM TO
FRESH AIR. GIVE CPR IF BREATHING IS STOPPED. GET MEDICAL ATTENTION.
ATTENTION. INGESTION: GET PROMPT MEDICAL ATTENTION. DO NOT INDUCE
VOMITING. KEEP AT REST.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:2
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:VAPORS HEAVIER THAN AIR.CAN TRAVEL A LONG
DISTANCE ALONG GROUND AND FLASHBACK.
* Accidental Release Measures *
Spill Release Procedures:ABSORB MATERIAL WITH CLAY, VERMICULITE, OR
SIMILAR ABSORBENT MATERIAL. PLACE IN DISPOSAL CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE ONLY IN WELL VENTILATED WORK AREA.
KEEP CONTAINERS CLOSED WHEN NOT IN USE. FLAMMABLE LIQUID; EMPTY
CONTAINERS CAN CONTAIN LIQUID/VAPOR RESIDUE.
Other Precautions:DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND, OR EXOPSE SUCH CONTAINERS TO HEAT, FLAME, SPARKS, STATIC
ELECTRICITY, OR OTHER SOURCES OF IGNITION. EXPLOSION HAZARD. EMPTY
DRUMS SHOULD BE C OMPLETELY DRAINED, BUNGED & DISPOSED OF.
* Physical/Chemical Properties *
HCC:F2
Evaporation Rate & Reference:3 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,COLORLESS LIQUID.MEDICINAL ALCOHOL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF ALL WASTE IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS. INCINERATION IS RECOMMENDED.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR IF IN
ENCLOSED AREAS OR IF ENGINEERING EQUIPMENT FAILS TO MAINTAIN
Ventilation:USE LOCAL EXHAUST TO MAINTAIN EXPOSURE LIMITS BELOW
REGULATORY LIMITS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER. HMIS: EYE
WASH STATION & SAFETY SHOWER. PROTECTIVE GARMETS FOR
PROLONGED/REPEATED USE.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
SAFETY/HEALTH: HMIS TECHNICIAN DISAGREES WITH MFR; CONTACT WITH A
SOLUTION OF A PH OF 1 WILL CAUSE CHEMICAL BURNS. BE VERY CAREFUL
WHEN HANDLING THIS MATERIAL.
* Product Identification *
CAGE:0THM1
CAGE:0THM1
* Composition/Information on Ingredients *
Ingred Name:PHOSPHORIC ACID (SARA III)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3/3 STEL
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
Ingred Name:ADDITIVES
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION IS NOT AN EXPECTED
ROUTE OF ENTRY UNDER NORMAL CONDITIONS OF USE. CONTACT MAY CAUSE
SKIN AND EYE IRRITATION. INGESTION MAY CAUSE GASTROINTESTINAL
IRRITATION. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: REDNESS, TEARING, BURNING SENSATION,
DISCOMFORT. SKIN: REDNESS, SWELLING, ITCHING. INGESTED: STOMACH
PAIN, NAUSEA, VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALED: REMOVE TO FRESH AIR. EYES: FLUSH WITH LOTS OF WATER
WITH SOAP AND WATER. INGESTED: DO NOT INDUCE VOMITING! IF
CONSCIOUS, GIVE MILK OR WATER. GET IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:ABSORB WITH INERT MATERIAL, NEUTRALIZE WITH
SODIUM CARBONATE AND FLUSH WITH WATER.
Neutralizing Agent:SODIUM CARBONATE
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM FREEZING, KEEP CONTAINER
TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:RECOMMENDED FOR INDUSTRIAL USE ONLY.
* Physical/Chemical Properties *
HCC:C1
Melt/Freeze Pt:M.P/F.P Text:NONE
pH:1
Evaporation Rate & Reference:SAME AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIS, STRONG OXIDIZING AGENTS, ZINC, LEATHER, NYLON FABRIC,
COLORED LAMINATES.
Stability Condition to Avoid:AVOID CONTACT WITH INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. ENSURE PH IS NEUTRAL BEFORE FLUSHING WITH
WATER. PHOSPHORIC ACID IS SUBJECT TO REPORTING UNDER TITLE 3 OF
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
W/CANISTER;SELF-CNTD BRTHG APPARTS
Ventilation:LOCAL EXHAUST & GENERAL MECHANICAL FOR AIR QUALITY < TLV
Other Protective Equipment:APRON,BOOTS,EYEWASH BOTTLE
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ETHYLENEDIAMINE (SARA III)
* Hazards Identification *
Effects of Overexposure:INGEST:BURNS MOUTH & STOMACH;SKIN/EYES:CAUSTIC
BURNS-SEVERE;INHAL:HEADACHE,NAUSEA,IRRITATES
* First Aid Measures *
First Aid:INGEST:DRINK PLENTY OF WATER;SKIN/EYES:FLUSH-WITH PLENTY OF
WATER;INHALATION:MOVE TO FRESH AIR & GIVE ARTIFICIAL RESPIRATION IF
REQUIRED.SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Lower Limits:5.8
Extinguishing Media:CARBON DIOXIDE,HALONES,DRY CHEMICALS,FOAM OR WATER
SPRAY
Fire Fighting Procedures:KEEP CONTAINERS
Unusual Fire/Explosion Hazard:CAN FORM EXPLOSIVE MIXTURE W/AIR
PARTICULARLY IN EMPTY UNCLEAN CONTAINERS
* Accidental Release Measures *
Spill Release Procedures:ATTEMPT TO STOP LEAK,PREVENT LIQUID FROM
ENTERING LOW SPACES,DIKE W/SAND OR EARTH,REMOVE
*Handling and Storage *
Other Precautions:AVOID BUILD-UP OF VAPORS.
* Physical/Chemical Properties *
HCC:F7
Appearance and Odor:CLEAR,COLORLESS LIQUID-STRONG AMMONIACAL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS,OXIDIZERS,CHLORINATED ORGANIC CMPDS,FLAMMABLE
Stability Condition to Avoid:SITUATIONS WHERE CONTACT W/STRONG
ACIDS,OXIDIZERS POSSIBLE
* Disposal Considerations *
Waste Disposal Methods:NEUTRALIZE & HANDLE AS ALL AMINES
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE SCBA.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:CHEMICAL APRON, EYE BATH, SAFETY SHOWER.
Work Hygienic Practices:WASH IF CONTACT IS MADE W/SKIN.
Supplemental Safety and Health
NK
* Product Identification *
Product ID:COPALTITE
* Composition/Information on Ingredients *
Ingred Name:PHENOLIC RESIN
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 PPM
Ingred Name:ETHYL ALCOHOL (ETHANOL)
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3 PPM
ACGIH TLV:1 PPM
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: SEVERE IRRITATION, REDNESS.
INHAL: DIZZINESS, DROWSINESS, TINGLING & PAIN IN HANDS & ARMS. EYE:
SEVERE IRRITATION, REDNESS, SWELLING, CHEMICAL BURNS.
Explanation of Carcinogenicity:NO COMMENT IS LISTED.
Medical Cond Aggravated by Exposure:ASTHMA & DERMATITIS.
* First Aid Measures *
First Aid:INGEST: INDUCE VOMIT, CALL DR. SKIN: REMOVE CONTAM CLOTHES,
MINUTES, SEE OPHTHALMOLOGIST. INHAL: REMOVE TO FRESH AIR.
* Fire Fighting Measures *
Flash Point Method:TOC
Lower Limits:6.7
Extinguishing Media:CO2, DRY CHEMICAL FOR SMALL FIRE, FOAM WATER FOG
FOR LARGE FIRE.
Fire Fighting Procedures:USE SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:MATERIAL MAY POLYMERIZE RAPIDLY & RUPTURE
CONTAINER.
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE CLOTHING, COLLECT FOR
DISPOSAL, DO NOT DISCHARGE TO WATERWAYS.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT/OPEN FLAME. STORE
* Physical/Chemical Properties *
Vapor Density:)2.3
Evaporation Rate & Reference:)4
Appearance and Odor:LIGHT COLORED PASTE, SLIGHT SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALI METALS, CONCENTRATED NITRIC-SULFURIC ACIDS, ACYL HALIDES,
ALDEHYDES & HOLOGENS.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:CO, CO2, TOXIC CRESOL VAPORS.
Conditions to Avoid Polymerization:EXTREME HEAT.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE WHERE ALLOWABLE BY
FEDERAL/STATE/LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AS REQUIRED
Ventilation:AS REQUIRED
Other Protective Equipment:AS REQUIRED
Work Hygienic Practices:PRACTICE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:DALE M. OREM
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
* Fire Fighting Measures *
Extinguishing Media:WATERSPRAY
Unusual Fire/Explosion Hazard:ANY ORGANIC POWDER CAN BE POTENTIALLY
EXPLOSIVE IF DISBURSED IN AIR IN CERTAIN CONCENTRATIONS. THESE
CONCENTRATIONS HAVE NOT BEEN DETERMINED.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP.
*Handling and Storage *
Other Precautions:USE OF THIS PRODUCT IN ACCORDANCE W/MANUFACTURER'S
INSTRUCTIONS SHOULD NOT RESULT IN EXPLOSIVE MIXTURES BEING FORMED.
* Physical/Chemical Properties *
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT TAN BROWN POWDER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF W/NORMAL LABORATORY TRASH. FOLLOW ALL
FEDERAL, STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WHEN
HF CONCENTRATION BELOW PERMISSIBLE EXPOSURE LIMIT.
Ventilation:USE LOCAL EXHAUST TO COMPLETELY REMOVE VAPORS AND FUMES
LIBERATED DURING HOT PROCESSING FROM WORK AREA.
Other Protective Equipment:LONG SLEEVE SHIRT IS RECOMMENDED.
Work Hygienic Practices:AVOID CONTAMINATION OF CIGARETTES OR TOBACCO
WITH POLYMER DUST.
Supplemental Safety and Health
HAZARDOUS DECOMPOSITION PRODUCTS: PERMISSIBLE EXPOSURE LIMIT FOR HF IS
3 PPM. PARTICULATE MATTER EVOLVED FROM OVERHEATING MAY CAUSE
POLYMER FUME FEVER. TOXIC FLUORINE COMPOUNDS EVOLVED IN FIRE.
* Product Identification *
Product ID:TEFLON FLUOROCARBON RESIN PTFE GRANULAR RES
Preparer's Name:W. H. MARTIN
* Composition/Information on Ingredients *
Ingred Name:ETHYLENE, TETRAFLUORO-, POLYMER; (POLYTETRAFLUOROETHYLENE)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGESTION/SKIN: NOT TOXIC. EYE:
MECHANICAL IRRITATION. INHALATION: WHEN THERMALLY DECOMPOSED BY
CONTAMINATED WITH POLYMER DUST, MAY CAUSE POLYMER FUME FEVER.
SYMPTOMS ARE FLU LIKE, WITH CHILLS AND FEVER, WHICH MAY NOT OCCUR
UNTIL SEVERAL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HEALTH HAZARDS: HOURS AFTER EXPOSURE AND PASS
RECOMMENDS TREATING POLYMER DUST AS NUISANCE PARTICULATE, AND HAS
NUISANCE PARTICULATES. CHRONIC: NONE KNOWN.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
First Aid:INHALATION: MOVE TO FRESH AIR. CONSULT PHYSICIAN IF SYMPTOMS
CONSULT PHYSICIAN IF SYMPTOMS PERSIST. SKIN: COOL RAPIDLY WITH COLD
WATE R. DO NOT ATTEMPT TO PEEL POLYMER FROM SKIN. OBTAIN MEDICAL
ATTENTION FOR THERMAL BURN. INGESTION: CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Flash Point Method:OC
Flash Point:DOES NOT FLASH
Extinguishing Media:WATER, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . DOES NOT BURN WITHOUT AN EXTERNAL FLAME.
Unusual Fire/Explosion Hazard:TOXIC FLUORINE COMPOUNDS EVOLVED IN FIRE.
HAZ COMBUSTION PRODUCTS: HYDROGEN FLUORIDE, CARBONYL FLUORIDE,
CARBON MONOXIDE AND LOW MOLECULAR WT FLUOROCARBONS.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP TO AVOID SLIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTAMINATION. KEEP CONTAINERS
CLOSED.
Other Precautions:AVOID CONTAMINATION OF CIGARETTES OR TOBACCO WITH
POLYMER DUST.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:2.1-2.3
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE GRANULES, NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MOLTEN ALKALI METALS, INTERHALOGEN COMPOUNDS.
SOURCE IS PRESENT (WILL BURN).
EVOLVE TOX GASEOUS MATLS SUCH AS HYDROGEN FLUORIDE &
PERFLUOROOLEFINS.OSHA(SUPDAT)
* Disposal Considerations *
Waste Disposal Methods:LANDFILL PREFERRED; DISPOSAL METHODS MUST
CONFORM TO FEDERAL, STATE, AND LOCAL REGULATIONS. WITH
INCINERATION, ACIDIC GASEOUS PRODUCT MUST BE REMOVED BY ALKALINE
SCRUBBING.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
EXPLO HAZ: INTERNALLY GENERATED STATIC ELECTRICITY. THERMAL DECOMP
PRODUCES HIGHLY TOXIC FUMES. SPILL PROC: TAKE UP & CONTAINERIZE FOR
PROPER DISPOSAL AS DESCRIBED UNDER DISPOSAL. COMPLY W/FEDERAL, ST
ATE & LOCAL REGS ON REPORTING RELEASES.REFER TO REGULATORY INFO FOR
REPORTABLE QUANTITY & OTHER REGULATORY DATA.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SULFUR
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE IRRITATING ON CONTACT WITH
SKIN, EYES OR MUCOUS MEMBRANES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:DATA NOT AVAILABLE.
* First Aid Measures *
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:
IMMEDIATELY FLUSH THOROUGHLY WITH LARGE AMOUNTS OF WATER. EYES:
INHALATION: REMOVE TO FRESH AIR; GIVE ARTIFICIAL RESPIRATION IF
BREATHING HAS STOPPED. INGESTION: GET IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:USE WATER, DRY CHEMICAL, CARBON DIOXIDE OR
"ALCOHOL" FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:SULFUR DUST SUSPENDED IN AIR IGNITES
EASILY & PRODUCES EXPLOSIVE FORCES IN CONFINED AREAS. IGNITION
SOURCES CAN BE HEAT, FRICTION, PROPHORIC SULFUR & (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA OF ALL UNNECESSARY PERSONNEL.
WEAR SUITABLE PROT EQUIP AS LISTED. ELIMINATE ANY IGNITION SOURCES
UNTIL AREA IS DETERMINED FREE FROM EXPLOSION OR FIRE HAZS. CONTAIN
RELEASE & ELIMINATE IT S SOURCE IF THIS CAN BE DONE W/OUT RISK.
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY, AREA AWAY FROM
OXIDIZING AGENTS. STORE AWAY FROM IGNITION SOURCES & INCOMPATIBLE
MATERIALS.
Other Precautions:DO NOT BREATHE DUST. DO NOT GET IN EYES, ON SKIN OR
ON CLOTHING.
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW RHOMBIC SOLID; ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NITRATES, CHLORATES, CHROMIC ANHYDRIDE, KMNO*4, PBO*2.
Stability Condition to Avoid:IGNITION SOURCES.
Hazardous Decomposition Products:SO*2.
* Disposal Considerations *
Waste Disposal Methods:MATL DOES NOT HAVE EPA WASTE NUMBER & IS NOT
LISTED WASTE, HOWEVER, CONSULTATION W/PERMITTED WASTE DISPOSAL SITE
(TSD) SHOULD BE ACCOMPLISHED. ALWAYS CONTACT PERMITTED WASTE
DISPOSER (TSD) TO ASSURE C OMPLIANCE W/ALL CURRENT LOCAL, STATE &
FED REGS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE DUST MASK WHEN SAWING OR GRINDING CURED
RESIN.
Ventilation:VENT CURING OVENS TO OUTDOORS.PROVIDE LOC EXH IN CONF AREAS
Other Protective Equipment:NONE
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:POLYAMIDE RESIN
Ingred Name:PIGMENTS & FILLERS
* Hazards Identification *
Effects of Overexposure:EYE:SEVERE IRRT DIRECT CONTACT.SKN:MOD IRRT
POSS SENSITIZATION.INH:NO SOLVENT VAP.INGES:LOW TOX
* First Aid Measures *
WATER. INHL:PROVIDE FRESH AIR.INGEST:NO ACTION NEEDED.
* Fire Fighting Measures *
Extinguishing Media:CO*2, FOAM, DRY CHEMICALS
Fire Fighting Procedures:USE SCBA WHEN FIGHTING FIRES INVOLVING THIS
MATERIAL.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:OBSERVE ALL PRECAUTIONS.VENTILATE CONFINED
AREAS. COLLECT SPILLAGE & PLACE IN APPROVED CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:USE ONLY IN WELL VENTILATED AREAS.
AVOID INHL DUST. AVOID CONTACT WITH EYES & SKIN. WASH CONTAMINATED
CLOTHING BEFORE REUSE.
Other Precautions:LAUNDER CONTAM CLOTHING BEFORE REUSE
* Physical/Chemical Properties *
Viscosity:PASTE
Solubility in Water:NIL
Appearance and Odor:GREEN VISCOUS PASTE WITH LITTLE ODOR
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:POSS CO,CO*2, N DECOMP PRODUCTS WHEN
EXP EXCESS HEAT,FLAME
* Disposal Considerations *
Waste Disposal Methods:CURED RESIN: DISPOSE IN APPROVED LANDFILL OR
INCINERATE PER REGS. UNCURED WASTES: INCINERATE IN APPROVED
DISPOSAL FACILITY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT ORDINARILY REQUIRED.
USED AT HIGH PRESSURE.
AS NEEDED TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:AVOID CONTACT WITH EYES.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:BARIUM DINONYLNAPHTHALENE SULFONATE
< Wt:2.
Ingred Name:DIISOPROPYL HYDROGEN PHOSPHITE
< Wt:2.
Ingred Name:OTHER COMPONENTS
Ingred Name:SYNTHETIC ESTER
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: PRODUCT IS PRESUMED TO BE
IRRITATING TO THE EYES. SKIN CONTACT: PROLONGED OR REPEATED CONTACT
MAY CAUSE VARIOUS SKIN DISORDERS SUCH AS DERMITITIS, FOLLICULITIS,
OR OIL ACNE. RELEASE DURIN G HIGH PRESSURE USAGE MAY RESULT IN
INJECTION OF OIL INTO THE SKIN CAUSING LOCAL NECROSIS. INHALATION:
NOT EXPECTED TO BE RELEVANT ROUTE OF EXPOSURE, HOWEVER, UNDER HIGH
TEMPERATURE CONDITIONS, VAPORS IRRITATING TO NOSE, THROAT, AND
UPPER RESPIRATORY TRACT MAY BE PRODUCED. INGESTION: NO SPECIFIC
INFORMATION IDENTIFIED.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN ANY
CARCINOGENS IDENTIFIED BY IARC, NTP, OR OSHA.
Effects of Overexposure:IRRITATION. LOCAL NECROSIS IS EVIDENCED BY
DELAYED ONSET OF PAIN AND TISSUE DAMAGE A FEW HOURS FOLLOWING
INJECTION.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
OPEN. GET MEDICAL ATTENTION. SKIN CONTACT: REMOVE CONTAMINATED
CLOTHING. WIPE EXCESS OFF. WASH WITH SOAP AND WATER OR WATERLESS
HAND CLEAN ER FOLLOWED BY SOAP AND WATER. LAUNDER CLOTHING BEFORE
REUSE. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. IF MATERIAL
INJECTED UNDER SKIN, GET MEDICAL ATTENTION TO PREVENT SERIOUS
DAMAGE. DO NOT WA IT FOR SYMPTOMS TO DEVELOP. INHALATION: MOVE TO
FRESH AIR. GIVE OXYGEN IF BREATHING DIFFICULT. GET MEDICAL
ATTENTION. INGESTION: DO NOT INDUCE VOMITING. NO TREATMENT
NECESSARY UNLESS LARGE QUANTITIES INGESTED. GET MEDICAL ADVICE.
* Fire Fighting Measures *
ESTIMATED
Extinguishing Media:USE WATER FOG. DRY CHEMICAL OR CO2. DO NOT USE A
DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE REIGNITED ON
SURFACE OF WATER.
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACE WITHOUT
PROPER PROTECTIVE EQUIPMENT INCLUDING A NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED CONTAINERS
SURROUNDING EQUIPMENT AND STRUCTURES WI TH WATER.`
* Accidental Release Measures *
Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPRIATE CLEANER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES. MINIMIZE SKIN CONTACT. WASH WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. DISPOSE OF LEATHER
ARTICLES.
Other Precautions:(CONTD FROM "WASTE DISPOSAL") MATERIAL MAY BE
RECYCLED. HAZARDOUS USED OIL RECYCLED BY BEING BURNED IS MINIMALLY
REGULATED UNDER RCRA (A VARIETY OF REQUIREMENTS MUST BE MET). USED
OIL RECYCLED IN OTH ER WAYS IS CURRENTLY EXEMPT FROM SUBTITLE C
REGULATIONS. CHECK LOCAL, STATE AUTHORITIES FOR OTHER RE GULATIONS.
* Physical/Chemical Properties *
HCC:V5
Evaporation Rate & Reference:N/A (NBUAC=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:TAN, SEMI-FLUID, SLIGHT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS. (CONTD. FROM "DECOMPOSITION PRODUCTS") THIS
MATERIAL UNDERGOES PYROLYSIS OR COMBUSTION. CARBON MONOXIDE AND
UNIDENTIFIED ORGANIC COMPOUNDS MAY BE FORMED UPON COMBUSTION.
Stability Condition to Avoid:HEAT, OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS ARE
HIGHLY DEPENDENT ON COMBUSTION CONDITIONS. A COMPLEX MIXTURE OF
AIRBORNE SOLID, LIQUID PARTICULATES AND GASES WILL EVOLVE WHEN
(CONTD. SEE "MATERIALS TO AVOID").
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Toxicological Information*
Toxicological Information:THIS SPECIFIC PRODUCT HAS NOT BEEN TESTED IN
LONG-TERM, CHRONIC TESTS. LUBRICATING GREASES ARE GENERALLY
CONSIDERED TO BE OF A LOW ORDER OF ACUTE TOXICITY TO HUMANS AND
EXPERIMENTAL ANIMALS. THIS PROD UCT DOES NOT CONTAIN ANY CARCINOGEN
IDENTIFIED BY IARC, NTP, OR OSHA. HOWEVER, THE HANDLING PROCEDURES
AND SAFETYPRECAUTIONS IN THIS MSDS SHOULD BE FOLLOWED TO MINIMIZE
EMPLOYEE'S EXPOSURE. BASED O N DATA AVAILABLE TO ROYAL, "OTHER
COMPONENTS" IN THIS PRODUCT IS NOT HAZARDOUS UNDER OSHA HAZARD
BEEN ESTABLISHED.
* Ecological Information *
Ecological:ENVIRONMENTAL HAZARDS: EPA-CLEAN WATER ACT (CWA). THIS
WATER ACT. SPILLS ENTERING (A) SURFACE WATERS OR (B) ANY
WATERCOURSES OR SEWERS EN TERING / LEAVING TO SURFACE WATERS THAT
CAUSE A SHEEN MUST BE REPORTED TO THE NATIONAL RESPONSE CENTER,
* Disposal Considerations *
EXTRACTED CONCENTRATION OF BARIUM AS SHOWN BY TOXICITY
CHARACTERISTIC LEACHING PROCEDURE (TCLP). REFER TO LATEST EPA OR
STAT E REGULATIONS. (CONTD. SEE "OTHER PRECAUTIONS")
* MSDS Transport Information *
Transport Information:NOT HAZARDOUS BY D.O.T. REGULATIONS.
* Regulatory Information *
PRODUCT CONTAINS BARIUM COMPOUNDS.
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE EPA / TSCA INVENTORY OF CHEMICAL SUBSTANCES.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A MSHA/NIOSH APPROVED, AIR PURIFYING, HALF
MASK OR FULL FACEPIECE RESPIRATOR W/APPROPRIATE FILTER PAD OR
CARTRIDGE.
Ventilation:LOCAL EXHAUST OR MECHANICAL
Supplemental Safety and Health
PRODUCTS ARE ALUMINOSILICATES WHICH MAY TRANSFORM UPON HEATING TO
MULLITE & CRISTOBALITE. REMOVAL OF THESE PRODUCTS AFTER SERVICE MAY
GENERATE DUST. PRODUCT CONTAINS MINOR AMOUNTS OF ORGANIC AND/OR IN
ORGANIC BINDERS WHICH BURN OUT DURING FIRST HEAT-UP.
* Product Identification *
Product ID:AIR-SET WET MORTAR
* Composition/Information on Ingredients *
Ingred Name:INORGANIC BINDERS
Ingred Name:SILICA CRYSTALLINE, SILICA (CRISTOBALITE) (SUSPECTED HUMAN
CARCINOGEN BY IARC)
OSHA PEL:SEE TABLE Z3
Ingred Name:SILICA, CRYSTALLINE - FUSED
OSHA PEL:SEE TABLE Z3
Ingred Name:PARTICULATES NOT OTHERWISE REGULATED (NUISANCE DUST)
OSHA PEL:5 MG/CUM
Ingred Name:FIBER SURFACE ORGANIC BINDERS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: DUST MAY CAUSE DELAYED
LUNG INJURY (SILICOSIS), IRRITATION OR DISCOMFORT OF
NOSE/THROAT/LUNGS. SKIN/EYES: IRRITATION.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE IS A SUSPECTED HUMAN
CARCINOGEN.
Effects of Overexposure:INHALATION: DUST MAY CAUSE DELAYED LUNG INJURY
(SILICOSIS), IRRITATION OR DISCOMFORT OF NOSE/THROAT/LUNGS.
SKIN/EYES: IRRITATION.
Medical Cond Aggravated by Exposure:BRONCHIAL DISORDERS
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK PLENTY OF
WATER. SKIN: WASH W/MILD SOAP & WATER. EYES: FLUSH W/PLENTY OF
WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Accidental Release Measures *
Spill Release Procedures:FOLLOW ROUTINE HOUSEKEEPING PROCEDURES.
COLLECT SPILLED PRODUCT IN CLOSED CONTAINER.
* Physical/Chemical Properties *
Spec Gravity:1.7-2.5
Solubility in Water:INSOLUBLE
Appearance and Odor:COLOR VARIES DEPENDING ON PRODUCT, NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:LANDFILL IN ACCORDANCE W/LOCAL, STATE, & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF THE EXPOSURE LIMIT IS EXCEEDED, USE NIOSH
APPROVED DUST RESPIRATOR.
Ventilation:ADEQUATE VENTILATION TO MEET THE EXPOSURE LIMITS (TLV).
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
* Product Identification *
Product ID:MILITARY MORTAR WET AIR SET MORTAR
* Composition/Information on Ingredients *
Ingred Name:CALCINED DIATOMACEOUS EARTH - CALCINED CLAY
Other REC Limits:NONE SPECIFIED
Ingred Name:KAOLIN
Other REC Limits:NONE SPECIFIED
Ingred Name:SILICATES - SILICATE OF SODA
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:2 MG/M3 (MFR)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF OVEREXPOSURE-PROLONGED
INHALATION OF THE DUSTS MAY CAUSE SERIOUS PULMONARY DISORDER.
SILICATE OF SODA MAY CAUSE EYE OR SKIN BURNS.
Explanation of Carcinogenicity:IARC HAS CLASSIFIED SILICA AS A CLASS 2A
CARCINOGEN.THERE IS LIMITED EVIDENCE FOR ITS CARCINOGENICITY.
Effects of Overexposure:SEE HEALTH HAZARDS SECTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:CONSULT A PHYSICIAN.SKIN:WASH OFF CONTACTED SKIN WITH WATER.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:NONE REQUIRED.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:IF PRODUCT IS DRY,USE DRY CLEAN-UP
PROCEDURES;AVOID DUSTING. COLLECT IN CONTAINERS OR BAGS. IF REUSE
OR RECYCLING IS NOT POSSIBLE, MATERIAL MAY BE DISPOSED OF AT A
SANITARY LANDFILL.
*Handling and Storage *
Handling and Storage Precautions:STORAGE-HANDLING EQUIPMENT SHOULD BE
DESIGNED TO KEEP AIRBORNE DUST TO A MINIMUM FOR WORKER COMFORT.
Other Precautions:DO NOT GET IN EYES. AVOID DUSTING. DO NOT BREATHE THE
DUST.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:NOT SOLUBLE
Appearance and Odor:TAN TO GREY FINE POWDER. WET AND ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
* First Aid Measures *
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR. AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UN CONSCIOUS PERSON VOMIT.
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
* Physical/Chemical Properties *
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
* Stability and Reactivity Data *
STRONG OXIDIZERS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:GOOD GEN VENTI SUFFICIENT TO CNTRL AIRBORNE LEVELS.LOC
EXHAU VENTI NECESSARY TO CNTRL AIR CONTAM W/IN TLV DURING USE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH CONTAMIN CLOTH SEPARATELY BEF REUSE.WASH
HANDS BEF EATING.
Supplemental Safety and Health
AWAY FROM SUCH VAP W/O SCBA. 1STAID:INHAL:REMOVE TO FRESH AIR.NOT
BREATH GIVE ART RESP.DIFFI BREATH GIVE OXY.GET MED ATTN. SPILL:
ABSORB W/INERT MATL(DRY SAND,EARTH),THEN PLACE IN CHEM WASTE CNTNR
FOR PROPER DISPO.
* Product Identification *
Preparer's Name:MICHAEL S. WATKINS
* Composition/Information on Ingredients *
Ingred Name:1,1,1,2-TETRAFLUOROETHANE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOSURE TO LIQ MAY CAUSE
FROSTBITE.EYE:IRRIT,MAY CAUSE FROSTBITE.SKIN:CAUSES FROSTBITE;PROL
CONTACT CAN CAUSE SKIN IRRIT.INGEST:UNLIKELY DUE TO VOLATILE NATURE
OF PRODUCT.CONTACT W/LIQ MAY CAUSE FRSO TBITE TO MOUTH/THROAT
TISSUES.INHAL:HARMFUL.HIGH CONCEN OF VAP IN IMMED AREA CAN DISPLACE
OXY,DIZZ,UNCONSC,DEATH(SUPPLE)
Explanation of Carcinogenicity:PER MSDS:CANCER INFO:NO INGREDS LISTED
AS HUMAN CARCINOGENS BY NTP/IARC.
Effects of Overexposure:FROSTBITE, EYE IRRIT, SKIN IRRIT.HARMFUL IF
INHAL.DIZZINESS,DISPLACES OXYGEN, UNCONSCIOUSNESS, DEATH.
Medical Cond Aggravated by Exposure:HEART, LUNG, SKIN, EYE.
* First Aid Measures *
First Aid:INGEST/SKIN/EYE:TREAT FOR POSSIBLE FROSTBITE.EYE:THEN FLUSH
W/PLENTY OF WATER.AFT INITIAL FLUSH REMOVE ANY CONTACT LENSE,CONT
PERSONNEL.SKIN:THEN WASH SKIN W/SOAP/WATER.REMVOE
COTNAMINCLOTH.IRRIT DEVELOPS/PERSIST GET MED ATTN.INGEST:SWALLOWING
LESS THAN OZ WILL NOT CAUSE SIGNIFICANT HARM.LG AMTS DO NOT INDUCE
VOMIT.GET MED ATTN IMMED.(SUPPLE)
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:NONE TO BOILING
Lower Limits:NON-FLAMM
Upper Limits:NON-FLAMM
Extinguishing Media:USE ALCOHOL FOAM, CARBON DIOXIDE, WATERSPRAY WHEN
FIGHTING FIRES INVOLVING MATL.
Fire Fighting Procedures:AS IN ANY FIRE WEAR SELF-CONTAINED BREATHING
APPARATUS(PRESSURE-DEAMDN,MSHA/NIOSH-APPROVED/EQUIVALENT)& FULL
PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:LG?SHUT OFF LEAK IF POSSIBLE,W/O RISK.WEAR
SCBA,APPROP PPE.ABSORB SPILL W/INERT MATL(DRY SAND,EARTH)THEN PLACE
IN CHEM WASTE CONTAINER FOR PROPER DISPO.DO NOT FLUSH TO
SEWER.AVOID RUNOFF INTO STORM SE WERS/DITCHES WHICH LEAD TO
WATERWAYS.SM:(SUPPLEME)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID PROL/REP EYE/SKIN/CLOTH
CONTACT.USE W/ADEQU VENTI.AVOID BREATH PROD VAP/MIST.DON'T REUSE
CNTNR.STORE IN COOL DRY PLACE AWAY FROM HEAT/SPARK/FLAM
Other Precautions:KEEP CNTNR CLSD WHEN NOT IN USE.DON'T STORE IN DIRECT
SUNLIGHT.KEEP OUT OF REACH OF CHILDREN.PRODUCT IS LEVEL 1
AEROSOL.DO NOT PUNCTURE/INCINERATE CNTNRS.NORMAL VENTI FOR STD MFG
PRACTICES USUALLY ADE QUATE.LOC EXHAU FOR WHEN LG AMTS RELEASE
* Physical/Chemical Properties *
HCC:G3
Boiling Pt:B.P. Text:NP
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NP
pH:NA
Evaporation Rate & Reference:>1, BUTYL ACETATE=1.
Appearance and Odor:CLEAR, COLORLESS LIQUEFIED GAS., WITH SLIGHT
ETHEREAL ODOR.
Corrosion Rate:NP
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
DO NOT MIX W/POWDERED ALKALI & ALKALINE EARTH METALS OR STRONG
OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT SPRAY NEAR OPEN FLAMES,RED HOT
SURFACES,OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY RELEASE
HYDROFLUORIC ACID VAPOR.
* Disposal Considerations *
Waste Disposal Methods:AVOID RUNOFF INTO STORM SEWERS/DITCHES WHICH
LEAD TO WATERWAYS.WATER RUNOFF CAN CAUSE ENVIRO DMG.REPORT SPILLS
THAT COULD REACH ANY SURFACE WATERS TO NAT RESP CNTNR
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
* Product Identification *
Preparer's Name:DOD HMIS/DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
OSHA PEL:0.2 FIBERS/CC
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
*Handling and Storage *
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
* Physical/Chemical Properties *
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:CHEMICAL CARTRIDGE RESPIRATOR IF IN CONFINED
AREA.
Ventilation:REQUIRED
Other Protective Equipment:RUBBER APRON
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:DIMETHAMETRYN
Ingred Name:NA PHENYL POLYGLYCOL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN ABSORPTION: HARMFUL. EYES:
CORROSIVE. INHALATION: IRRITATING TO THROAT, NASAL PASSAGES &
MUCOUS MEMBRANES. INGESTION: NAUSEA & VOMITING.
Explanation of Carcinogenicity:NONE
* First Aid Measures *
First Aid:SKIN: RINSE IMMEDIATELY W/WATER. EYES: FLUSH IMMEDIATELY
AIR. INGESTION: RINSE MOUTH & GIVE PLENTY OF WATER TO DRINK. INDUCE
VOMITIN G. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:CO2, FOAM, DRY CHEMICAL, WATER SPRAY
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DECOMPOSITION & COMBUSTION PRODUCTS MAY
BE TOXIC.
* Accidental Release Measures *
Spill Release Procedures:MOP UP W/WATER OR ABSORB SPILL W/AN ABSORBENT
MATERIAL (I.E. SELIG'S AP ABSORBENT), PICK UP & DEPOSIT IN A
SUITABLE WASTE CONTAINER. FLUSH AREA THOROUGHLY W/A DETERGENT
SOLUTION. RINSE AREA THOROUGHLY W/CLEAN WATER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
DON'T STORE, POUR OR SPILL NEAR HEAT SOURCE OR OPEN FLAME.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. HARMFUL IF SWALLOWED.
AVOID CONTACT W/SKIN & EYES. AVOID PROLONGED EXPOSURE TO VAPORS.
* Physical/Chemical Properties *
Appearance and Odor:CLEAR-COLORLESS LIQUID, SLIGHT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT
Hazardous Decomposition Products:TOXIC/CORROSIVE GASES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS OR ORGANIC VAPOR RESPIRATOR OR SUPPLIED-AIR RESPIRATOR,
IF NEEDED.
Ventilation:LOCAL/MECHANICAL (GENERAL) VENTILATION - EXPLOSION PROOF,
WELL GROUNDED EQUIPMENTS
Other Protective Equipment:IMPERVIOUS CLOTHING TO AVOID SKIN AND EYE
CONTACT. EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH EYES, SKIN OR CLOTHING. WASH
HANDS AFTER USING PRODUCT. AVOID BREATHING VAPORS OR MISTS.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:N-HEPTANE, 1-2%
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHYL TERT-BUTYL ETHER (SARA III), 0-2%
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BENZINE (MOTOR FUEL)/GASOLINE - INCLUDES COMPOUNDS LISTED
BELOW
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BENZENE (SARA III), 1-5%
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PENTANE, 1-4%
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA III), 0-4%
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HEXANE (N-HEXANE), 1-3%
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BUTANE/N-BUTANE, 1-3%
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL BENZENE (SARA III), 1-2%
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE- INHALATION OF VAPORS MAY CAUSE
CNS DEPRESSION, CONVULSION, LOSS OF CONSCIOUSNESS. INGESTION HAS
SYMPTOMS SIMILAR TO INHALATION & ASPIRATION HAZARD. EYE/SKIN
CONTACT CAUSES IRRITATION. CHRONIC- DERMATITIS, NERVOUS SYSTEM,
KIDNEY, LIVER & BLOOD DISORDERS INCLUDING ANEMIA & LEUKEMIA. KIDNEY
CANCER IN LAB ANIMALS.
Explanation of Carcinogenicity:CONTAINS BENZENE. MAY CAUSE BLOOD
DISEASES INCLUDING LEUKEMIA. VAPORS MAY CAUSE KIDNEY CANCER IN MALE
RATS.
Effects of Overexposure:HEADACHE, NASAL & RESPIRATORY IRRITATION,
NAUSEA, DROWSINESS, FATIGUE, EYE & SKIN IRRITATION, PULMONARY
EDEMA, CONVULSION & LOSS OF CONSCIOUSNESS
Medical Cond Aggravated by Exposure:BENZENE- INDIVIDUALS WITH LIVER,
KIDNEY AND BLOOD DISEASES. HEXANE- INDIVIDUALS WITH NEUROLOGICAL
DISEASES. PETROLEUM SOLVENT- THOSE WITH EXISTING DERMATITIS.
* First Aid Measures *
First Aid:CALL A PHYSICIAN IN ALL CASES. EYES:IMMEDIATELY FLUSH WITH
WATER. INHALED:REMOVE TO FRESH AIR & PROVIDE CPR/OXYGEN IF
NECESSARY. ORAL: DO NOT INDUCE VOMITING UNLESS INSTRUCTED BY A
PHYSICIAN. CALL A PHYSICIAN IMMEDIATELY. IF VOMITING OCCURS
SPONTANEOUSLY, KEEP HEAD BELOW HIPS.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.5
Upper Limits:7.6
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL AND
VAPORIZING LIQUID TYPE EXTINGUISHERS. WATER MAY BE INEFFECTIVE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT & A
FULL FACED SELF CONTAINED BREATHING APPARATUS/SUPPLIED-AIR
RESPIRATOR.COOL FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:THE INVISIBLE VAPORS ARE HEAVIER THAN AIR
AND TRAVEL SOME DISTANCE TO IGNITION SOURCES & FLASH BACK. CAN FORM
FLAMMABLE MIXTURE WITH AIR & FLASH AT ROOM TEMP.
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENTS.ELIMINATE ALL
SOURCES OF IGNITION.USE EXPLOSION-PROOF TOOLS.SHUT OFF FUEL
SOURCE.DIKE SPILL.PREVENT LIQUID FROM ENTERING
SEWERS/WATERWAYS.RECOVER FREE LIQUID.ADD SAND,EARTH OR OTHER
ABSORBENT MATERIAL.TRANSFER TOCONTAINER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN ACCORDANCE WITH NATIONAL FIRE
PROTECTION ASSOCIATION REGULATIONS. KEEP CONTAINERS CLOSED.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE AND CAN BE
DANGEROUS. DO NOT PRESSURIZE, CUT, WELD, SOLDER, DRILL OR EXPOSE
SUCH CONTAINERS TO HEAT, FLAME, SPARKS. THEY MAY EXPLODE AND CAUSE
INJURY/DEATH. AVOID REP EATED OR PROLONGED CONTACT WITH SKIN.
* Physical/Chemical Properties *
HCC:F2
Melt/Freeze Pt:M.P/F.P Text:NOT KNOWN
Vapor Density:>3
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID - GASOLINE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, SPARKS, OPEN FLAMES AND OTHER
SOURCES OF IGNITION
Hazardous Decomposition Products:FUMES, CARBON MONOXIDE, CARBON DIOXIDE
AND OTHER DECOMPOSITION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:RECYCLE AS MUCH AS POSSIBLE. TREATMENT, STORAGE,
TRANSPORTATION AND DISPOSAL MUST BE IN ACCORDANCE WITH ALL
APPLICABLE LOCAL, STATE AND FEDERAL LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
HYPOCHLORITE. NEUTRALIZE THE SOLUTION BEFORE FLUSHING DOWN THE
DRAIN. OB SERVE ALL FEDERAL, STATE AND LOCAL LAWS.
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. CAUSES EYE IRRITATION. CAUSES SKIN
IRRITATION. MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND UPPER
RESPIRATORY TRACT.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:IMMEDIATELY FLUSH EYES WITH COPIOUS AMOUNTS OF WATER FOR AT
AMOUNTS OF WATER. INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING GIVE
ARTIFICIALRESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
CALL MD. INGEST: CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:NONCOMBUSTIBLE. USE EXTINGUISHING MEDIA APPROPRIATE
TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
* Accidental Release Measures *
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED SCBA, RUBBER BOOTS
WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA AND WASH SPILL
SITE AFTER MATERIAL PICKUPIS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. HYGROSCOPIC.
STORE IN A COOL, DRY PLACE.
Other Precautions:DO NOT BREATHE DUST. DO NOT GET IN EYES, ON SKIN ON
CLOTHING. DO NOT USE IF SKIN IS CUT OR SCRATCHED. IRRITANT.
* Physical/Chemical Properties *
Appearance and Odor:WHITE CRYSTALS
* Stability and Reactivity Data *
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SO*X.
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE MATL IN 1) WATER; 2) ACID SOLN; OR 3)
OXIDIZED TO A WATER-SOLUBLE STATE. PRECIP MATL AS SULFIDE,
ADJUSTING PH OF SOLN TO 7.0 TO COMPLETE PRECIP. FILTER INSOL & DISP
IN A HAZ WASTE SITE. DESTR OY EXCESS SULFIDE WITH SODIUM (SEE
SUPPDATA)
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED.
IF VAPOR CONCENTRATION RISES ABOVE TLV USE NIOSH APPROVED ORGANIC
RESPIRATOR OR SELF-CONTAINED BREATHING APPARATUS.
Ventilation:USE ADEQUATE VENTILATION TO MAINTAIN TLV AND PREVENT
ACCUMULATION OF VAPORS IN LOW LYING AREAS.
Other Protective Equipment:NONE.
Work Hygienic Practices:DO NOT GET IN EYES, SKIN, CLOTHING. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:JOHN ROUDEBUSH
* Composition/Information on Ingredients *
Ingred Name:ISOHEXANE
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
Other REC Limits:NONE RECOMMENDED
Ingred Name:HEXANE (N-HEXANE)
Fraction by Wt: 2-3%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CARBON DIOXIDE (AEROSOL ONLY)
Fraction by Wt: 4%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:VAPOR & LIQUID MAY CAUSE IRRIT.
SKIN:PROLONGED/REPEATED CONTACT MAY CAUSE DRYING OF SKIN. CAN BE
ABSORBED THROUGH SKIN. INHAL:IRRIT MUCOSAL TISSUE AT HIGH
CONCENTRATION. INGEST:UNLIKELY ROUTE OF E XPOSURE. HOWEVER, MINUTE
AMOUNTS ASPIRATED INTO LUNGS DURING INGESTION MAY CAUSE CHEMICAL
PNEUMONIA.
Effects of Overexposure:EYE IRRIT. DRYING OF SKIN. HEADACHE, LIGHT
HEADEDNESS, GIDDINESS, CENTRAL NERVOUS SYSTEM DEPRESSION. MUCOSAL
TISSUE IRRIT. CHEMICAL PNEUMONIA.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY DISORDERS.
* First Aid Measures *
First Aid:EYE:FLUSH W/PLENTY OF COLD WATER. CONTACT PHYSICIAN.
SKIN:WASH W/SOAP & WATER. APPLY MEDICATED SKIN CREAM. INHAL:MOVE TO
FRESH AIR. CONTACT PHYSICIAN. GIVE OXYGEN IF INDICATED. INGEST:DO
NOT INDUCE VO MITING. CONTACT PHSYSICIAN IMMED.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.2
Upper Limits:7.7
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS
APPROVED BY NIOSH. USE WATER TO KEEP CONTAINERS COOL.
Unusual Fire/Explosion Hazard:FIRE'S INTENSE HEAT WILL CAUSE AEROSOLS
TO BURST.FLAMM VAPORS WHICH ARE HEAVIER THAN AIR MAY ACCUMULATE IN
LOW AREAS &/OR SPREAD ALONG GROUND AWAY FROM HANDLING
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA;VENTILATE.REMOVE LEAKING
CONTAINER & TRANSFER REMAINING PRODUCT TO ANOTHER VESSEL.MOP OR
SOAK UP SPILL W/ABSORBENT MATERIAL & TRANSFER TO DISPOSAL DRUMS
USING NON-SPARKING EQUIPMT.STORE IN CLOSED CONTAINERS.DO NOT FLUSH
PRODUCT TO SEWER
Neutralizing Agent:NONE STATED.
*Handling and Storage *
BREATHING VAPORS & PROLONGED SKIN CONTACT.
Other Precautions:VAPORS WILL COLLECT IN LOW AREAS. USE AND STORE WITH
ADEQUATE VENTILATION. BOND AND GROUND DURING TRANSFER OF LIQUID.
* Physical/Chemical Properties *
HCC:V3
Vapor Density:3.0
Evaporation Rate & Reference:<1, ETHYL ETHER=1
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH MILD ALCOHOL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXYGEN AND STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:OPEN FLAMES, ELECTRIC ARCS AND OTHER HOT
SURFACES WHICH MAY CAUSE THERMAL DECOMPOSITION.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, IF
BURNED.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS FOR FLAMMABLE HYDROCARBONS OR RECLAIM BY
DISTILLATION. THIS MATL HAS THE RCRA CHARACTERISTIC OF IGNITABILITY
AND IF DISCARDED IN ITS PURCHASED FORM WOULD HAVE THE HAZ
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED. IF ENGINEERING CONTROLS
FAIL OR NON-ROUTINE USE OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH
APPROVED RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE OR AN AIR-SUPPLIED
Ventilation:USE ADEQUATE EXPLOSION-PROOF MECHANICAL VENTILATION OR
LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. COVERALLS,
APRON OR OTHER EQUIPMENT SHOULD BE WORN TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:DIACETONE ALCOHOL (4-HYDROXY-4-METHYL-2-PENTANONE)
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE EFFECTS ARE POSSIBLE IRRITATION
& DISCOMFORT. XYLENE CAUSES CNS EFFECTS, ANEMIA, LIVER & KIDNEY
EFFECTS & EYE DAMAGE AFTER REPEATED OR PROLONGED EXPOSURE TO HIGH
CONCENTRATIONS BY SKIN ABSORPTIO N AND INHALATION. HARMFUL OR FATAL
IF SWALLOWED. VAPOR HARMFUL. ASPIRATION MAY CAUSE CHEMICAL
PNEUMONITIS, EDEMA, DEATH.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALATION-RESPIRATORY TRACT IRRITATION,
HEADACHE, DIZZINESS, NAUSEA, VIMITING, MALAISE. SKIN-IRRITATION,
DERMATITIS. EYES-IRRITATION, DISCOMFORT. INGESTED-VOMITING.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN, EYE, OR
RESPIRATORY DISORDERS MAY BE AGGRAVATED THROUGH PROLONGED EXPOSURE.
* First Aid Measures *
First Aid:IN ALL CASES GET MEDICAL ATTENTION. EYES-FLUSH WITH WATER FOR
MILD SOAP & WATER. INHALED-REMOVE TO FRESH AIR. GIVE OXYGEN OR
ARTIFICI AL RESPIRATION AS NEEDED. INGESTED-DO NOT INDUCE VOMITING!
IF VOMITING OCCURS, KEEP HEAD BELOW HIPS.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:2.0
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, CHEMICAL
FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL FIRE FIGHTER'S PROTECTIVE GEAR. USE WATER TO COOL FIRE EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS CAN EXPLODE DUE TO
BUILD-UP OF PRESSURE WHEN EXPOSED TO EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE & VENTILATE AREA. ELIMINATE ALL
SOURCES OF IGNITION. CONFINE & ABSORB SPILLED MATERIAL. PLACE
MATERIAL INTO APPROVED CONTAINERS FOR DISPOSAL. FOR SPILLS IN
EXCESS OF ALLOWABLE LIMITS (RQ) NOT IFY NATIONAL RESPONSE CENTER AT
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
PROTECT CONTAINERS FROM ABUSE & EXTREME TEMPERATURES. KEEP AWAY
FROM SOURCES OF IGNITION.
Other Precautions:"EMPTY" CONTAINERS MAY CONTAIN RESIDUE WHICH CAN FORM
EXPLOSIVE VAPORS. DO NOT WELD OR CUT NEAR EMPTY CONTAINERS THAT
HAVE NOT BEEN PROFESSIONALLY RECONDITIONED. USE NON-SPARKING TOOLS
WHEN OPENING & CLOSING CONTAINERS.
* Physical/Chemical Properties *
HCC:F3
Vapor Density:>1
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:MODERATE
Appearance and Odor:RED LIQUID; CHARATERISTIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ACIDS.
Stability Condition to Avoid:EXTREME TEMPERATURES, OPEN FLAMES, SPARKS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
WATERWAY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATORY PROTECTION IF TLV IS
EXCEEDED.
Ventilation:LOCAL EXHAUST. MECHANICAL AS REQUIRED TO MEET TLV.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Preparer's Name:M. WINSEL
* Composition/Information on Ingredients *
Ingred Name:SILICONE RESIN (CONTAINING INGREDIENT 2)
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:N/K
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPANE; (PROPANE PROPELLANT)
ACGIH TLV:ASPHYXIANT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ANESTHESIA, HEADACHE, DIZZINESS,
NAUSEA, EYE IRRITATION, DRYING OF SKIN. CHRONIC: TOLUENE APPEARS ON
THE NAVY LISTING OF OCCUPATIONAL CHEMICAL REPRODUCTIVE HAZARDS.
SEEK CONSULTATION FROM APPROPRIATEHEALTH PROFESSIONALS CONCERNING
LATEST HAZARD LIST INFORMATION AND SAFE HANDLING AND EXPOSURE (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: INFORMATION . THIS PRODUCT CONTAINS A
CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
SKIN: WASH WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND
LAUNDER BEFORE REUSE. INHALATION: FRESH AIR, OXYGEN, ARTIFICIAL
RESPIRATION IF NECESSARY. INGESTION: DO NOT INDUCEVOMITING. SLOW
DILUTE WITH 1-2 GLASSES OF WATER OR MILK AND SEEK MEDICAL
ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Flash Point Method:OC
Extinguishing Media:CARBON DIOXIDE, CHEMICAL FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . TOXIC FUMES WILL BE FORMED UPON COMBUSTION.
Unusual Fire/Explosion Hazard:CAN BURST IF EXPOSED TO TEMPERATURES
* Accidental Release Measures *
Spill Release Procedures:PICK UP WITH AN INERT ABSORBENT MATERIAL.
STORE IN SEALED METAL CONTAINERS FOR DISPOSAL.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:AVOID HIGH TEMPERATURES AND IGNITION
SOURCES. STORE IN A COOL, VENTILATED AREA.
Other Precautions:AVOID INHALATION AND REPEATED OR PROLONGED SKIN
CONTACT.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:AEROSOL
Vapor Density:>1
Evaporation Rate & Reference:1.5
Solubility in Water:NOT SOLUBLE
Appearance and Odor:CLEAR, COLORLESS; TOLUENE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:HEAT AND IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SILICON DIOXIDE AND FORMALDEHYDE.
* Disposal Considerations *
Waste Disposal Methods:LICENSED INCINERATION OR PER FEDERAL, STATE AND
LOCAL GOVERNMENT REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF >TLV, USE NIOSH/MSHA JOINTLY APPROVED AIR
SUPPLIED RESPIRATOR.
Ventilation:IF >TLV, USE LOCAL EXHAUST. MECHANICAL (GENERAL): REQUIRED.
SPARK PROOF FAN SUGGESTED.
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS.
Work Hygienic Practices:FOLLOW GOOD HOUSEKEEPING & PERSONAL HYGIENE
PRACTICES. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS
Ingred Name:FORMALDEHYDE, FORMALIN (2A CARCINOGEN BY NTP, IARC, OSHA)
INTENDED CHANGE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYES:
BURNING/TEARING/REDNESS/SWELLING. SKIN: MINOR
BURNING/ITCHING/REDNESS. INGESTION: BLINDNESS. INHALATION:
ABSORPTION IS RAPID RESULTING IN COMPOUNDED EFFECTS INCLUDING
SEVERE INTOXICATION/DIZZINE SS/VISUAL
IMPAIRMENT/NAUSEA/HEADACHES/RESPIRATORY FAILURE/MUSCULAR
INCOORDINATION/NARCOSIS/TOXIC/SYSTEMIC EFFECTS.
Explanation of Carcinogenicity:FORMALDEHYDE IS A 2A SUSPECTED HUMAN
CARCINOGEN.
Effects of Overexposure:EYES: BURNING/TEARING/REDNESS/SWELLING. SKIN:
MINOR BURNING/ITCHING/REDNESS. INGESTIN: BLINDNESS. INHALATION:
ABSORPTION IS RAPID RESULTING IN COMPOUNDED EFFECTS INCLUDING
SEVERE INTOXICATION/DIZZINES S/VISUAL
IMPAIRMENT/NAUSEA/HEADACHES/RESPIRATORY FAILURE/MUSCULAR
INCOORDINATION/NARCOSIS/TOXIC/SYSTEMIC EFFECTS.
* First Aid Measures *
First Aid:INGESTION: DON'T INDUCE VOMITING. ADMINISTER LUKEWARM WATER
(PINT) IF PERSON IS CONSCIENCE. SKIN: WASH W/SOAP & WATER. EYES:
ADMINISTER ARTI FICIAL RESPIRATION IF NECESSARY. OBTAINMEDICAL
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:2%
Extinguishing Media:WATER MIST, FOG, CO2, PURPLE K, DRY CHEMICAL,
ALCOHOL RESISTANT FOAM.
Fire Fighting Procedures:WEAR POSITIVE PRESSURE SCBA. WATER MAY BE
INEFFECTIVE IN "INDEPTH" METHANOL FIRES. USE FINE WATER SPRAY/FOG
TO CONTROL FIRE SPREAD/TO COOL CONTAINER/STRUCTURE.
Unusual Fire/Explosion Hazard:ISOPROPANOL PORTION IS >AIR & MAY TRAVEL
LONG DISTANCES ALONG GROUND BEFORE LIGHTING & FLASHING BACK.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF IGNITION. AVOID BREATHING
VAPORS, VENTILATION AREA. COLLECT W/INERT ABSORBENT & PLACE IN
CONTAINER FOR DISPOSAL. DON'T ALLOW TO ENTER SEWER. IF SEWER ENTRY,
DILUTE W/PLENTY OF WATER & NOTIFY PROPER AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:GROUND STORAGE VESSELS. USE SPARK
PROOF TOOLS. DON'T LEAVE CONTAINER OPEN TO ATMOSPHERE. AVOID
STORAGE IN ALUMINUM/LEAD/RUBBER LINED VESSELS.
Other Precautions:ADEQUATE VENTILATION & FIRE PROOF AREA. AVOID CONTACT
W/SKIN. DON'T TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN. AVOID
STORAGE OR USE NEAR INCOMPATIBLE MATERIALS. AVOID INHALATION OF
VAPORS.
* Physical/Chemical Properties *
Evaporation Rate & Reference:(BU AC = 1): <4.6%
Solubility in Water:MISCIBLE
Appearance and Odor:DARK BLUE, CLEAR LIQUID, STRONG FORMALIN ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS/ALUMINUM/ZINC/ANY REACTIVE METAL WHICH WILL
DISPLACE HYDROGEN, PLASTICS, RUBBER, & ITS COATING
Stability Condition to Avoid:HEAT, SPARKS, OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CO, CO2, FORMALDEHYDE, FORMIC ACID
* Disposal Considerations *
Waste Disposal Methods:LANDFILL IN ACCORDANCE W/LOCAL, STATE, & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF INCINERATED, USE NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS OR SUPPLIED AIR RESPIRATOR WITH
FULL FACEPIECE, OPERATED IN POSITIVE PRESSURE MODE.
Ventilation:USE ADEQUATE LOCAL EXHAUST VENTILATION WHEN FUMES PRESENT.
Other Protective Equipment:EYE WASH STATION, QUICK DRENCH SHOWER AND
IMPERVIOUS CLOTHING
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
* Composition/Information on Ingredients *
Ingred Name:NICKEL OXIDE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3 AS NI
ACGIH TLV:1 MG/M3 AS NI
POTASSIUM HYDROXIDE)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 2 MG/M3
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 MG (CD)/M3 DUST
Fraction by Wt: 9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1MG/M3 FUME/1 DUST
Ingred Name:NYLON II
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY,
GI TRACTS. ACUTE- CONTENTS OF AN OPEN BATTERY (KOH) CAN CAUSE
SEVERE IRRITATION/BURNS TO TISSUE CONTACTED. CAN CAUSE BLINDNESS.
NICKEL MAY CAUSE SKIN SENSITIZATI ON. INGESTION CAN BE
HARMFUL/FATAL. CHRONIC- CADMIUM MAY CAUSE LUNG OR KIDNEY DAMAGE.
NICKEL MAY CAUSE LUNG DAMAGE.
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN. ALSO
CONTAINS NICKEL
Effects of Overexposure:NONE UNDER NORMAL CONDITIONS OF USE. IF LEAKING
OR INCINERATED: SEVERE IRRITATION, BURNS, CHEST PAIN, COUGHING,
SWEATING, CHILLS, SHORTNESS OF BREATH, WEAKNESS, BLINDNESS, NICKEL
ITCH
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED KIDNEY OR RESPIRATORY FUNCTION
MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
* First Aid Measures *
First Aid:GET MEDICAL ATTENTION IMMEDIATELY. EYE/SKIN:IF CONTACT WITH
POTASSIUM HYDROXIDE ELECTROLYTE, IMMEDIATELY FLUSH WITH WATER FOR
PROVIDE OXYGEN/CPR IF NEEDED. ORAL:DO NOT INDUCE VOMITING. IF
CONSCIOUS, DRINK LARGE AMOUNT OF WATER OR MILK.
* Fire Fighting Measures *
Flash Point:NONE
* Accidental Release Measures *
Spill Release Procedures:BATTERY AND CELL CASES WILL NORMALLY CONTAIN
MATERIALS OF CONCERN. USE INDUSTRIAL ABSORBENT TO COLLECT LIQUID
ACID.
Neutralizing Agent:CITRIC ACID
*Handling and Storage *
Handling and Storage Precautions:DO NOT SHORT CIRCUIT. AVOID BREAKING,
CRUSHING OR OTHERWISE DESTROYING THE PHYSICAL INTEGRITY OF THE CELL
OR BATTERY. KEEP AWAY FROM FLAME & SPARKS.
Other Precautions:DO NOT INCINERATE. DO NOT TOUCH BROKEN OR LEAKING
BATTERIES. WASH THOROUGHLY AFTER HANDLING. AVOID BREATHING FUMES.
KEEP OUT OF REACH OF SMALL CHILDREN. NO SMOKING DURING BATTERY
CHARGING. ALWAYS USE EXTREME CARE. AVOID OPEN FLAME.
* Physical/Chemical Properties *
Viscosity:NOT RELEVANT
* Stability and Reactivity Data *
Hazardous Decomposition Products:TOXIC FUMES OF CADMIUM OXIDE, NICKEL
OXIDE, CADMIUM, POTASSIUM HYDROXIDE
* Disposal Considerations *
Waste Disposal Methods:CELLS AND BATTERIES MAY BE RETURNED TO SAFT FOR
RECYCLING OR AT SENDERS EXPENSE TO A PERMITTED TREATMENT, STORAGE,
DISPOSAL FACILITY (TSDF). DISPOSAL MUST BE MADE IN ACCORDANCE WITH
ALL APPLICABLE FED ERAL, STATE AND LOCAL LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST AND GENERAL VENTILATION AS REQUIRED, TO
MAINTAIN EMISSIONS BELOW TLV-TWA OR PEL.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
FOOTWEAR, OTHER PROTECTIVE CLOTHING AS REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFFECTS OF OVEREXPOSURE:EVENTUALLY CAUSE SYSTEMIC POISONING AND/OR
CENTRAL NERVOUS SYSTEM DEPRESSION. CENTRAL NERVOUS SYSTEM DEPRESS
IS CHARACTERIZED BY HEADACHE, DIZZINESS, NAUSEA, VOMITING, DROWSINE
SS, ABDOMINAL PAIN AND INCOORDINATION. SEVERE (ING 6)
* Product Identification *
Preparer's Name:BRUCE RIVOIRO
* Composition/Information on Ingredients *
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (PETROLEUM
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: 1-7%
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: 1-5%
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:OVEREXP MAY LEAD TO RESP FAILURE, COMA & POSSIBLY
Ingred Name:ING 9:CONJ UPON RPTD CONT. INHAL:SOLV VAP MAY CAUSE IRRIT
WAS OBSERVED. TARGET ORGANS:SKIN, BLOOD, KIDNEY, LIVER, LUNGS.
Ingred Name:EYE PROT:& FULL LENGTH FACESHIELD .
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN:POSSIBLE IRRITATION, DEFATTING
DERMATITIS, ESPECIALLY WITH REPEATED OR PROLONGED EXPOSURE.
EYE:SEVERE IRRITATION. INHALATION:SOLVENT VAPORS MAY CAUSE
IRRITATION TO UPPER RESPIRATORY TRACT AND LEA D TO CENTRAL NERVOUS
SYSTEM DEPRESSION.CNS DEPRESS IS CHARACTERIZED BY HEADACHE,
DIZZINESS, NAUSEA, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:VOMITING, DROWSINESS, ABDOMINAL PAIN
AND INCOORDINATION. SEVERE OVEREXPOSURE MAY LEAD TO RESPIRATORY
FAILURE AND POSSIBLY DEATH. OTHER CNS EFTS ARE ALSO POSSIBLE.
INGESTION:CAUSES IRRITATION AND BURNING OF MOUTH.
CHRONIC:SKIN:SOLVENTS MAY BE ABSORBED THRU INTACT SKIN AND (SUPDAT)
Medical Cond Aggravated by Exposure:SOME PRE-EXISTING EYE, SKIN AND
RESPIRATORY DISORDERS.
* First Aid Measures *
GET MED AID. SKIN: IMMED WASH AFFECTED AREAS W/SOAP & WATER. GET
MED AID IF SYMPS PERSIST. REMOVE CONTAMD CLTHG. INGEST: GIVE 2
GLASSES OF W ATER TO DRINK IF PATIENT IS CONSCIOUS. DO NOT INDUCE
VOMIT. GET MED AID IMMED. INHAL: MOVE PATIENT TO FRESH AIR. RESTORE
BRTHG IF NECESSARY. KEEP PATIENT WARM & QUIET. GET MED AID
IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE,
UNIVERSAL-TYPE FOAM APPLIED BY MANUFACTURERS' RECOMMENDED
TECHNIQUES.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROTECTIVE EQUIPMENT
. ISOLATE HAZ AREA. USE WATER SPRAY TO COOL FIRE-EXPOSED CNTNRS &
ALSO DISPERSE VAPS; RE-IGNIT IS POSSIBLE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL
TO SOURCE OF IGNITION & SUBSEQUENTLY "FLASH BACK" TO SOURCE OF
PRODUCT DISCHARGE CAUSING FIRE OR EXPLOSION.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. STOP AND
CONTAIN DISCHARGE (IF W/OUT RISK) BY CONSTRUCTING BARRIERS OR
APPLYING INERT SORBENT (E.G. SAND, EARTH). PREVENT DISCHARGE FROM
ENTERING SEWERS OR WATER COURSE S.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, WELL VENTILATED
ENVIRONMENT. KEEP AWAY FROM HEAT, SPARKS AND OTHER SOURCES OF
IGNITION.
Other Precautions:GROUND AND BOND ALL EQUIPMENT AND CONTAINERS TO
PREVENT A POSSIBLE STATIC CHARGE BUILDUP. USE SPARK-RESISTANT
TOOLS.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:<1 (NBUAC =1)
Solubility in Water:NOT KNOWN
Appearance and Odor:LIQUID, VARIOUS COLORS - MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND BASES.
Stability Condition to Avoid:EXCESSIVE HEAT, IGNITION SOURCES (E.G.
SPARKS, STATE ELECTRIFICATION, FLAME, ETC), INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:COMBUSTION...CARBON DIOXIDE, CARBON
MONOXIDE PLUS OTHER ORGANIC OR INORGANIC OXIDES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE/PROPERLY CONTAINED, CONTAMD
SOLIDS IN APPRVD WASTE TREATMENT FACILITY WHERE PERMITTED UNDER
APPROP FEDERAL, PROVINCIAL, STATE AND LOCAL REGULATIONS. DO NOT
DISPOSE OF WASTE IN LOCAL S EWERS OR WITH NORMAL REFUSE.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE ORGANIC VAPOR RESPIRATOR (AIR
PURIFYING/FRESH AIR). OBSERVE OSHA REGS (RESPIRATOR USE). PROVIDE
VENT (KEEP EXPOSURE LEVELS BELOW OSHA LIMITS). VAPOR PARTIC RSPRTR
Ventilation:EXHAUST VENT SUFFICIENT TO KEEP AIRBORNE CONC
(SOLVENT/POLYISOCYANATES/HDI) BELOW TLV'S. REMOVE ALL IGNITION
SOURCES.
Other Protective Equipment:FACE SHIELDS. THE USE OF LONG SLEEVE AND
LONG LEG CLOTHING IS RECOMMENDED.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING, SMOKING OR USING WASHROOM.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
Preparer's Name:NORM GAUL
* Composition/Information on Ingredients *
Ingred Name:ALIPHATIC ISOCYANATE (VAPOR PRESSURE: 0 MM HG)*
Other REC Limits:NONE SPECIFIED
MONOMER CONTENT LESS THAN 0.7% BASED ON RESIN SOLIDS AT TIME OF**
Other REC Limits:NONE SPECIFIED
Ingred Name:**MANUFACTURE. AFTER 3-6 MO STORAGE, THE FREE MONOMER
Other REC Limits:NONE SPECIFIED
Other REC Limits:NONE SPECIFIED
Ingred Name:N-BUTYL ACETATE (SARA III)
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
HG)
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
Other REC Limits:NONE SPECIFIED
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: VAPORS IRRITATING TO
EYES/NOSE/THROAT. INHALATION: IRRITATION, ACUTE NERVOUS SYSTEM
DEPRESSION. CHRONIC: PROLONGED CONTACT WILL CAUSE DEFATTING ACTION.
INGESTION: IRRITATION. ASPIRATION CAN CAU SE CHEMICAL PNEUMONITIS.
AS A RESULT OFPREVIOUS REPEATED OVEREXPOSURE OR SINGLE LARGE DOSE,
CERTAIN INDIVIDUALS WILL**
Effects of Overexposure:INHAL: DIFFICULT BREATHING, HEADACHE,
DIZZINESS, STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS, COMA. SKIN:
IRRIT (SWELLING/REDNESS/RASH). EYES: REDNESS, TEARING, SWELLING
W/STINGING. SKIN: SWELL/REDNES S/RASH. PROLONG/REPEAT--MOD IRRIT,
DRYING, SKIN CRACKING. INGEST: VOMIT. IRRIT. CORROSIVE TO
MOUTH/STOMACH/DIGEST TRACT.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS.
* First Aid Measures *
First Aid:INHALATION: MOVE TO FRESH AIR. RESTORE BREATHING. ASTHMATIC
TYPE SYMPTOMS MAY DEVELOP (IMMED/DELAYED BY SEVERAL HRS). GET MED
AID. SKIN: REMOVE CONTAM CLOTHING. WASH AREA W/SOAP & WATER. WASH
CONTAM C LOTHING BEFORE REUSE. EYES: FLUSH WITH LUKEWARM WATER (LOW
INGESTION: DON'T INDUCE VOMIT. NOTHING BY MOUTH TO UNCONSCIOUS
PERSON. GET MED AID.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:FULL FIRE FIGHT EQUIP W/SCBA & FULL PROTECT
CLOTH. USE WATER TO COOL CLOSED CNTNRS/PREVENT PRESSURE
BUILD-UP/AUTO IGNITE/EXPLOSION. HDI/IRRIT VAPORS GENERATED.
Unusual Fire/Explosion Hazard:KEEP FROM IGNITE SOURCES. CLOSED CNTNR
MAY EXPLODE W/HEAT. USE SPECIAL PRECAUTION W/APPLIC TO HOT SRFCS.
DURING EMERG COND, OVEREXPOS TO DECOMP PROD/HEALTH HZD.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN BLDG IN COMPLIANCE W/OSHA
CLOSED CONTAINERS. STORE IN WELL VENT AREAS.
Other Precautions:KEEP CNTNRS TIGHT/UPRIGHT (PREVENT LEAKAGE). NO
PROLONGED BREATHING OF VAPORS/SPRAY MISTS. AVOID CONTACT
W/SKIN/EYES. DO NOT TAKE INTERNALLY. DO NOT HANDLE UNTIL THE SAFETY
PRECAUTIONS HAVE BEEN READ/ UNDERSTOOD. SMOKE ONLY IN SMOKING
AREAS.
**DEVELOP ISOCYANATE SENSITIZATION WHICH WILL CAUSE THEM TO REACT TO A
LATER EXPOSURE OF ISOCYANATES LEVELS WELL BELOW THE TLV VALUE OF
ISOCYANATES.
* Physical/Chemical Properties *
HCC:F2
Vapor Density:> AIR
Viscosity:*
Evaporation Rate & Reference:3.7 X N-BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID WITH SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:CONTACT WITH MOISTURE, MATERIALS WHICH
REACT WITH ISOCYANATES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN, TRACES OF HCN AND
HDI.
* Disposal Considerations *
Waste Disposal Methods:WASTE MUST BE DISPOSED IN ACCORD W/FEDERAL,
STATE & LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY CONTAINERS
MUST BE HANDLED W/CARE (PRODUCT RESIDUE/FLAMMABLE VAPOR). DON'T
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . LAB COAT SHOULD BE WORN WHEN HANDLING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MATLS TO AVOID:PRODUCE FLAMMABLE & EXPLOSIVE HYDROGEN GAS. CAN REACT
W/OTHER CHEMICALS LIBERATING TOXIC VAPORS. EYE PROT:& FULL LENGTH
FACESHIELD .
* Product Identification *
Preparer's Name:STEPHEN M. BACON
* Composition/Information on Ingredients *
Ingred Name:N,N-DIETHYL-P-PHENYLENEDIAMINE, OXALIC ACID SALT;
(N,N-DIETHYL-PHENYLENEDIAMINE OXALATE)
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: 2.8%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3;3 STEL
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATING TO SKIN AND EYES. CONTACT
WITH SKIN CAN CAUSE DERMATITIS. INGESTION CAN CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, CRAMPS AND DIARRHEA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . SKIN:WASH THOROUGHLY W/SOAP & WATER. IF IRRITATION PERSISTS
OR DERMATITIS DEVELOPS, GET MEDICAL ATTENTION. EYES:FLUSH WELL (FO
NOT INDUCE VOMITING. CONTACT MD IMMEDIATELY & GIVE LARGE AMOUNTS OF
WATER OR LARGE AMOUNTS OF WATER W/MILK OF MAGNESIA.
* Fire Fighting Measures *
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTACT W/SOME METALS CAN RESULT IN
EVOLUTION OF FLAMMABLE HYDROGEN GAS. CAN PRODUCE TOXIC PO*X & NO*X
FUMES & PHOSPHINES UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:ABSORB W/VERMICULITE OR OTHER INERT MATERIAL &
CONTAINERIZE FOR LATER DISPOSAL.
Neutralizing Agent:NEUTRALIZE W/SODA ASH.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:CORROSIVE ACID.
* Physical/Chemical Properties *
pH:1.3
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS, WATERLIKE LIQUID; ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STABLE IN CNTNR, BUT CAN REACT VIGOROUSLY W/STRONG OXIDIZING AGENTS &
CONC CAUSTIC. AS AN ACID, REACT W/METAL TO(SUPDAT)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CAN PRODUCE HYDROGEN GAS & TOXIC
VAPORS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF BY INCINERATION OR OTHER METHOD
APPROVED OF BY LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED SCBA WHERE VAPOR
CONCENTRATION MAY BE ABOVE TLV LIMITS. WHERE VAPORS DOES NOT EXCEED
TLV LIMITS, USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:ADEQUATE VOLUME AND PATTERN TO KEEP AIR CONCENTRATION BELOW
CURRENT APPLICABLE OSHA OR ACGIH'S TLV LIMITS.
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING RESTROOM.
SMOKE IN SMOKING AREA ONLY.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
CAGE:0HKF5
CAGE:0HKF5
* Composition/Information on Ingredients *
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Ingred Name:4-HEPTANONE, 2,6-DIMETHYL-; (DIISOBUTYL KETONE). VP:1.7 @
Fraction by Wt: <5%
Fraction by Wt: <5%
Fraction by Wt: <5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY CAUSE EYE, NOSE AND SKIN
IRRITATION, HEADACHE, NAUSEA AND VOMITING. CHRONIC:LONG TERM
EXPOSURE MAY LEAD TO CNS DEPRESSION PULMONARY EDEMA AND KIDNEY
DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:INHAL:MAY CAUSE NASAL AND RESPIRATORY
IRRITATION. EYES:MAY CAUSE IRRITATION. SKIN:MAY CAUSE IRRITATION.
SKIN ABSORPTION:MAY CAUSE IRRITATION. INGEST:MAY CAUSE IRRITATION,
NAUSEA AND VOMITING.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. EYES:FLUSH IMMEDIATELY WITH LARGE
WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. INGEST:DO NOT
INDUCE V OMITING. GET MD ATTENTION IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.8%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE. WATER MAY BE USED TO
COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP. WEAR
NIOSH/MSHA APPROVED SCBA AND FULL PROT EQUIP .
Unusual Fire/Explosion Hazard:FIRE EXPOSED CONTAINERS MAY RUPTURE DUE
TO PRESSURE BUILD-UP.
* Accidental Release Measures *
Spill Release Procedures:PROVIDE VENTILATION. REMOVE ALL SOURCES OF
IGNITION. LARGE SPILLS MAY BE SCOOPED UP WITH NON-SPARKING TOOLS.
SMALL SPILLS MAY BE PICKED UP WITH ABSORBENT MATERIALS
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM HIGH TEMPERATURES,
SPARKS AND OPEN FLAMES. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PROLONGED CONTACT.
* Physical/Chemical Properties *
HCC:F3
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:1.3
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGABLE
Appearance and Odor:WHITE LIQUID WITH CHARACTERISTIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT AND OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YEILD CO*2
AND CO.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE OF IN AN APPROVED INCINERATOR.
DISPOSAL MUST BE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC CANISTER MASK/AIR
PACK.
Ventilation:RECOMMENDED TO KEEP VAPOR CONCENTRATION BELOW TLV.
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: ACCUMULATE IN LOW AREAS/AREAS INADEQUATELY VENTD. VAPS MAY
ALSO TRAVEL ALONG GROUND TO BE IGNITED @ LOCATIONS DISTANT FROM
HANDLING SITE. FLASH BACK OF FLAME TO HANDLING SITE MAY OCCUR.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:4-HEPTANONE,2,6-DIMETHYL-; (2,6 DIMETHYL-4-HETANONE). VP:
1.7
Fraction by Wt: 5%
Fraction by Wt: 5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, NOSE & THROAT BY
VAPORS, SKIN IRRITATION BY LIQUID, VERY HIGH VAPOR LEVELS CAN CAUSE
FLUSHING, HEADACHE, DIZZINESS, MENTAL DEPRESSION, NAUSEA, VOMITING,
NARCOSIS, COMA. NOTE: TOLUE NE APPEARS ON NAVY LISTING OF
OCCUPATIONAL CHEMICAL REPRODUCTIVE HAZARDS. SEEK CONSULTATION (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: FROM APPROPRIATE HEALTH PROFESSIONALS
CONCERNING LATEST HAZARD LIST INFORMATION AND SAFE HANDLING AND
EXPOSURE INFORMATION .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR, GIVE OXYGEN IF BREATHING IS DFCLT.
IF UNCON, APPLY ARTF RESP. CALL A PHYSICIAN. SKIN: FLUSH WITH
MINUTES. IN GEST: DO NOT INDUCE VOMITING.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:0.8%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . DO NOT USE A DIRECT STREAM OF WATER. PRODUCT
WILL FLOAT AND CAN BE REIGNITED.
Unusual Fire/Explosion Hazard:CONTRS EXPOSED TO INTENSE HEAT FROM FIRES
SHOULD BE COOLED W/WATER TO PVNT VAP PRESS BUILDUP WHICH COULD RSLT
IN CONTR RUPTURE. VAPS ARE HVR/AIR & MAY (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:AVOID OPEN FLAME/SPARK SOURCES, PROVIDE ADEQ
VENT. NIOSH/MSHA APPRVD SUPPLIED AIR RESP PROT SHOULD BE USED FOR
LG SPILLS/SPILLS IN CONFINED SPACES. SM SPILLS-FLUSH W/LG QTY OF
WATER; LG SPILLS-COLLECT FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:WARNING!! FLAMMABLE-BREATHING OF VAPOR
MAY BE HARMFUL. LIQUID MAY CAUSE EYE IRRITATION. KEEP AWAY FROM
HEAT, SPARKS AND OPEN FLAME.
Other Precautions:KEEP CONTAINER CLOSED. USE W/ADEQUATE VENTILATION.
AVOID PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT
W/EYES.
* Physical/Chemical Properties *
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS, STRONG MINERAL ACIDS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CARBON MONOXIDE AND/OR CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:PLACE IN A DISPOSAL FACILITY APPROVED UNDER RCRA
REGULATIONS FOR HAZARDOUS WASTE. USE NON-LEAKING CONTAINERS, SEAL
TIGHTLY AND LABEL PROPERLY. DISPOSE OF I/A/W FEDERAL, STATE AND
LOCAL REGULATIONS (FP N).
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA. WHEN SANDING, WIREBRUSHING,
ABRADING, BURNING OR WELDING, WEAR A PARTICULATE RESPIRATOR
APPROVED BY NIOSH/MSHA.
Ventilation:LOCAL EXHAUST/GENERAL
Work Hygienic Practices:WASH HANDS AFTER USING. REMOVE/LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. DON'T SMOKE.
Supplemental Safety and Health
SOLVENTS WITH PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ETHYL ACETATE
Ingred Name:BUTYL ACETATE (N-BUTYL ACETATE)
Ingred Name:TOLUENE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION/RED/ITCHING & BURN.
SKIN: ABSORPTION/IRRITATION/RED/ITCHING & BURN. INHALATION:
RESPIRATORY IRRITATION/CNS
DEPRESSION/UNCONSCIOUSNESS/DEATH/HEADACHE/DIZZINESS/NAUSEA/LOSS OF
COORDINATI ON/AFFECTS
LIVER/URINARY/BLOOD-FORMING/CARDIOVASCULAR/REPRODUCTIVE
SYSTEM/HARMFUL/FATAL/PERMANENT BRAIN & CNS DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE: IRRITATION/REDN/ITCHING & BURN. SKIN:
ABSORPTION/IRRITATION/RED/ITCHING & BURN. INHALATION: RESPIRATORY
IRRITATION/CNS
DEPRESSION/UNCONSCIOUSNESS/DEATH/HEADACHE/DIZZINESS/NAUSEA/LOSS OF
COORDINAT ION/AFFECTS
LIVER/URINARY/BLOOD-FORMING/CARDIOVASCULAR/REPRODUCTIVE
SYSTEM/HARMFUL/FATAL/PERMANENT BRAIN & CNS DAMAGE.
* First Aid Measures *
WASH THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Lower Limits:0.7%
Upper Limits:6.7%
Extinguishing Media:CO2, DRY CHEMICAL & FOAM
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. USE WATER USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. CLOSED
CONTAINERS MAY BUILD-UP PRESSURE, EXPLODE OR AUTOIGNITE WHEN
EXPOSED TO EXTREME HEAT. FLAMMABLE.
* Accidental Release Measures *
Spill Release Procedures:REMOVE W/INERT ABSORBENT. ELIMINATE IGNITION
SOURCES.
*Handling and Storage *
Handling and Storage Precautions:AVOID INHALATION OF VAPOR OR SPRAY
MIST & CONTACT W/SKIN & EYES. KEEP CONTAINER CLOSED WHEN NOT IN
USE. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE &
APPROPRIATE LABELING. DON'T TAKE INTERNALLY. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING & INHALING THE CONTENTS CAN BE HARMFUL &
FATAL.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:SEE SUPP.
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN
FLAME, PILOT LIGHTS & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO2, CO
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL BY INCINERATION IN COMPLIANCE W/LOCAL,
STATE, & FEDERAL REGULATIONS. DON'T INCINERATE CLOSED CONTAINER.
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE & APPROPRIATE
LABELING. THIS PRODUCT MA Y BE HAZARDOUS AS DEFINED UNDER RCRA.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHEN SPRAYING OR APPLYING IN CIRCUMSTANCES
LIKELY TO PRODUCE AIRBORNE LEVELS OF HAZARDOUS INGREDIENTS IN
EXCESS OF TLV, USE ORGANIC VAPOR CARTRIDGE OR AIR SUPPLIED
RESPIRATOR.
Ventilation:GENERAL VENTILATION TO MAINTAIN VAPORS BELOW PEL AND TLV.
Other Protective Equipment:AVOID SKIN CONTACT BY USE OF OTHER
PROTECTIVE EQUIPMENT. DURING SPRAY APPLICATION COMPLETE SKIN
PROTECTION REQUIRED.
Work Hygienic Practices:SAFETY SHOWER, EYE BATH AND WASHING FACILITIES.
Supplemental Safety and Health
NK
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:METHYL AMYL KETONE (VP = 2.1 MM HG)
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL-3-ETHOXYPROPIONATE (VP = 1.1 MM HG)
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 5.0%
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Ingred Name:HOMOPOLYMER OF HEXAMETHYLENE DIISOCYANATE (HDI)
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: BURNING, TEARING, REDDENING,
CORNEAL INJURY, PAIN, SWELLING. SKIN: DRYING, CRACKING, DERMATITIS,
REDNESS, BURNING, IRRIT, SWELLING, SENSITIZATION. INHAL: DIZZY,
DROWSY, FATIGUE, NASAL/RESPIRATORYIRRIT, CNS EFFECTS, NAUSEA,
HEADACHE, UNCONSCIOUS, LIVER/KIDNEY DAMAGE, CHEST PAIN, COUGHING,
THROAT IRRIT, ANESTHETIC,
Effects of Overexposure:MUCOUS MEMBRANE IRRIT, RUNNY NOSE. INGEST:
DROWSY, DIZZY, NAUSEA, IRRIT & CORROSIVE ACTION IN MOUTH, STOMACH
TISSUE, AND FDIGESTIVE TRACT.
* First Aid Measures *
DONT USE SOLVENTS. REMOVE CONTAM CLOTHES, WASH BEFORE REUSE. INHAL:
REMOVE TO FRESH AIR. ARTIF RESP/CPR IF NEEDED. INGEST: CALL DR. IN
ALL CASES, GET IMMED MED AID.
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. COOL
CONTAINERS W/WATER. FOG NOZZLES PREFERRED. USE SCBA AND PROTECTIVE
CLOTHES. CLOSED CONTAINERS EXPLODE IN HIGH HEAT.
Unusual Fire/Explosion Hazard:VAPORS COLLECT IN POORLY VENTED OR
CONFINED AREAS. VAPORS FORM EXPLOSIVE MIXTURES W/AIR. VAPORS TRAVEL
TO IGNITS AND FLASH BACK.
* Accidental Release Measures *
Spill Release Procedures:PROTECT FROM IGNITS. USE AIR SUPPLIED
FOR UNVENTED SPILLS. COVER W/ABSORBENT. ADD DECOMP
Neutralizing Agent:*DECOMP SOLUTION: 5% CONCENTRATED AMMONIA, 2%
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. ISOLATE
Other Precautions:EMPTY DRUMS MAY CONTAIN EXPLOSIVE VAPORS. DONT CUT,
PUNCTUREOR WELD ON OR NEAR DRUM. DURING A FIRE, IRRITATING AND
TOXIC GASES AND AEROSOLS FROM DECOMPOSITION/COMBUSTION PRODUCTS MAY
BE PRESENT.
* Physical/Chemical Properties *
Vapor Density:>AIR
Evaporation Rate & Reference:NA
Appearance and Odor:CLEAR LIQUID, SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONTACT W/WATER, ALCOHOLS AND AMINES.
Hazardous Decomposition Products:CARBON DIOXIDES AND CARBON MONOXIDE.
MAY ALSO INCLUDE OXIDES OF NITROGEN AND TRACES OF HCN AND
ISOCYANATE MONOMER.
* Disposal Considerations *
Waste Disposal Methods:WHEN DISPOSING OF THIS MATERIAL, INSURE THAT IT
IS PACKAGED, STORED, TRANSPORTED AND OTHERWISE PACKAGED IN
ACCORDANCE W/FEDERAL, STATE AND LOCAL REGULATIONS.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED; HOWEVER USE OF ADEQUATE
VENTILATION IS GOOD INDUSTRIAL PRACTICE.
Ventilation:CONTROL AIRBORNE CONCENTRATIONS BELOW THE EXPOSURE
GUIDELINES.
Supplemental Safety and Health
* Product Identification *
Product ID:SUPER PERMALUBE GREASE
* Composition/Information on Ingredients *
Ingred Name:SOLVENT REFINED HYDROTREATED HEAVY PARAFFINIC DISTILLATE,
OSHA PEL:5 MG/CUM (MIST)
Ingred Name:LITHIUM SOAP THICKENER
Ingred Name:ZINC DIALKYL DITHIOPHOSPHATE
Fraction by Wt: 1-5%
Ingred Name:ZINC COMPOUND
Fraction by Wt: 0.5-1.5%
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: PROLONGED/REPEATED CONTACT MAY
PRODUCE SOME IRRITATION.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION
* First Aid Measures *
First Aid:EYES: FLUSH W/PLENTY OF WATER. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO UNCONTAMINATED AREA. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, CO2, FOAM, STEAM/WATER FOG
Fire Fighting Procedures:WEAR FULL BUNKER GEAR W/A POSITIVE PRESSURE
SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:REMOVE MECHANICALLY/CONTAIN ON AN ABSORBENT
MATERIAL SUCH AS DRY SAND/EARTH. KEEP OUT OF SEWERS & WATERWAYS.
*Handling and Storage *
Handling and Storage Precautions:NO SPECIAL REQUIREMENTS.
* Physical/Chemical Properties *
Solubility in Water:<0.1%
Appearance and Odor:GREEN COLORED, SMOOTH GREASE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CHLORINE, FLUORINE, OTHER STRONG OXIDIZERS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:INCOMPLETE BURNING: CO, CO2, OTHER
HARMFUL PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:ENCLOSED-CONTROLLED INCINERATION IS RECOMMENDED
UNLESS DIRECTED OTHER WISE BY APPLICABLE ORDINACES. DISPOSE OF
IAW/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHEN ESTABLISHED AIRBORNE EXPOS LIMS ARE
SURPASSED, WEAR NIOSH/MSHA APPRVD EQUIP. DETERM APPROP TYPE EQUIP
FOR SPECIFIC APPLICATION BY CONSULTING RESP MFR. OBSERVE RESP USE
Ventilation:MAINTAIN AIRBORNE CONCS BELOW ESTABLISHED EXPOS LIMS BY
Other Protective Equipment:WEAR PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THORO AFTER HNDLG, ESP BEFORE EATING,
DRINKING, SMOKING/USING RESTROOM FACILITIES. CONTAM CLTHG & SHOES
Supplemental Safety and Health
USERS OF "L" VERSION SHOULD CONSULT "LR" VERSION FOR ADDNL INFO . HAZ
DECOMP PROD:CARBON MONOXIDE). FIRST AID PROC:OF WATER/BY STICKING
FINGER DOWN THROAT. DO NOT GIVE ANYTHING BY MOUTH IF PERS IS
DROWSY, UNCON/HAS NO GAG REFLEX. INGEST CREATES HIGH RISK OF ASPIR
& SUBSEQUENT CHEM PNEUM. HOWEVER, PRESENCE (ING 3)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT:CAN CAUSE MILD TO MODERATE
IRRITATION. SEVERITY OF REACTION DEPENDS ON DURATION OF EXPOSURE &
FIRST AID PROCEDURES ADMINISTERED. SKIN:IRRITATION CAN OCCUR
FOLLOWING PROLONGED OR REPEATED C ONTACT. INHAL:UNDER NORMAL
CONDITIONS OF USE, NO ADVERSE EFFECTS ARE EXPECTED.
INGEST:INGESTION CAN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CAUSE GASTROINTESTINAL IRRITATION.
DEPENDING OF THE ROUTE, FREQUENCY & DURATION OF EXPOSURE, TOXICITY
MAY OCCUR IN THE FOLLOWING ORGANS &/OR SYSTEMS: EYE.
Medical Cond Aggravated by Exposure:EXPOSURE TO THIS PRODUCT IS NOT
EXPECTED TO CONTRIBUTE TO, WORSEN OR AGGRAVATE ANY EXISTING MEDICAL
CONDITIONS.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF
CONSULT MD. SKIN:REMOVE CONTAM CLTHG & SHOES. WASH AFFECTED AREA
W/SOAP & WA TER. IF IRRIT DEVELS, CONSULT MD. WASH CONTAM CLTHG
SEPARATELY BEFORE REUSE. INGEST:SEEK MED ATTN. UNLESS ADVISED
OTHERWISE, INDUCE VOMIT BY EITHER GIVING SYRUP OF IPECAC FOLLOWED
BY 2 GLASSES(SUPDAT)
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:SM FIRES:USE DRY CHEM, CARBON DIOXIDE, HALON, WATER
SPRAY/FOAM. LG FIRES:USE WATER SPRAY, FOG/ALCOHOL FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY LIBERATE IRRITATING OR TOXIC VAPORS
DURING COMBUSTION OR DECOPOSITION.
* Accidental Release Measures *
Spill Release Procedures:STOP DISCHARGE, IF IT CAN BE PERFORMED SAFELY
& CONTAIN MATL. IF SUBSTANTIAL QTY IS SPILLED, RECOVER
W/PUMP/VACUUM TRUCK. EXPLO-PROOF EQUIP SHOULD BE USED IF THIS PROD
IS FLAMM/COMBUST. OTHERWISE, USE ABSORB SUCH AS FULLER'S EARTH,
CLAY/OTHER (ING 5)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID BRTHG VAP &/OR MIST. STORE IN
COOL, DRY, WELL-VENTILATED AREA. DO NOT STORE NEAR HEAT/IGNIT
SOURCES/IN DIRECT SUNLIGHT.
Other Precautions:ALWAYS KEEP CNTNRS TIGHTLY CLSD TO AVOID CONTAM.
SPECIAL WARNING:HOT ORG CHEM VAPS/MISTS CAN SUDDENLY & W/OUT
WARNING COMBUST WHEN MIXED W/AIR. IGNIT CAN OCCUR AT TYPICAL
* Physical/Chemical Properties *
Evaporation Rate & Reference:<1 (ETHYL ETHER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK REDDISH LIQUID; LIKE GAS OIL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, REDUCING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:IF HEATED TO HIGH TEMPS, THIS PROD MAY
EMIT FOLLOWING CMPDS:SMOKE, SOOT & TOX FUMES (E.G., CARBON DIOXIDE
& (SUPP DATA)
* Disposal Considerations *
Waste Disposal Methods:IF DISCARDED IN ITS ORIGINAL UNUSED FORM, THIS
PROD SHOULD BE MANAGED (STORED/TREATED/DISP/ETC) AT AUTH FACILITY,
IN COMPLIANCE W/ALL APPLIC FED, STATE & LOC REQUIREMENTS. BE SURE
TO CONT APPROP GOVT ENVIRON AGENCIES IF FURTHER DISP GUIDANCE (ING
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:LOCAL EXHAUST OK.
Other Protective Equipment:NONE
Supplemental Safety and Health
IF THIS PRODUCT BECOMES A WASTE, IT WOULD NOT BE A HAZARDOUS WASTE BY
ARE INDIVIDUALLY NOT CLASSIFIED TO BE RCRA HAZARDOUS WASTES BY TH E
SAME CRITERIA.
* Product Identification *
Product ID:NATURE'S WAY READY-TO-USE BIODEGRADABLE CLEANER
* Composition/Information on Ingredients *
Ingred Name:THERE ARE NO HAZARDOUS INGREDIENTS ACCORDING TO THE
MANUFACTURER
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NA
ACGIH TLV:NA
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: EXCESSIVE INHALATION MAY
CAUSE LUNG IRRITATION. INGESTION: MAY CAUSE CONSULVSIONS. SKIN: MAY
CAUSE SKIN IRRITATION IF LEFT ON FOR LONG PERIOD OF TIME. EYES: MAY
CAUSE EYE IRRITATION.
Effects of Overexposure:MAY CAUSE LUNG IRRITATION.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. IF LUNG IRRITATION OCCURS,
CONSULT PHYSICIAN. INGESTION: DRINK SEVERAL GLASSES OF WATER AND
CONSUILT A PHYSICIAN. SKIN: IF IRRITATION OCCURS, RINSE THOROUGHLY
WITH WAT ER FOR AT LEAST 5 MINUTES. IF IRRITATION PERSISTS, CONSULT
LIDS APART TO ENSURE COMPLETE IRRIGATION. IF IRRITATION PERSISTS,
SEE DR.
* Fire Fighting Measures *
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NONFLAMMABLE
Fire Fighting Procedures:NONE KNOWN
Unusual Fire/Explosion Hazard:NONE KNOWN
*Handling and Storage *
Handling and Storage Precautions:STORE INDOORS. STORE AWAY FROM STRONG
OXIDIZERS.
Other Precautions:NONE KNOWN
* Physical/Chemical Properties *
pH:NEUTRL
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR W/CITRUS ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:BIODEGRADABLE PRODUCT. DISPOSE OF CONTAINER
ACCORDING TO STATE, FEDERAL AND LOCAL LAWS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CNTRLS DONT MAINTAIN AIRBORNE
CONC BEL RECOMMENDED EXPO LIMITS APPROV RESP MUST BE WORN.RESP
TYPE:FULL-FACE ORG VAP CARTRIDGE.RESP USED A PROGRAM SHOULD BE
Ventilation:SE PROCESS ENCLOSURES,LOC EXHA VENTI,OTHER ENGINEERING
CNTRLS TO MAINTAIN AIRBORNE LEV BEL RECOMMENDED EXPO LIMITS.
Other Protective Equipment:PROTECTIVE CLOTHING APPRORIATE FOR RISK OF
EXPOSURE.EYEBATH,SAFETY SHOWER,WASHING FACILITIES.
Work Hygienic Practices:WASH CONTAM CLOTH BEF REUSE;DESTROY/THOROUGHLY
CLEAN CONTAM SHOES.WASH THOROUGHLY AFT HNDLG.
Supplemental Safety and Health
OTH PREC:GROWTH OF PLANTS,LOW POT TO PERSIST IN ENVIRO,LOW POT TO
BIOCONC.AFT DIL W/LG AMT OF H2O/2ND WASTE TREAT MATL NOT EXPECTED
TO CAUSE ADVERSE ENVIRO EFFECTS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID (CERCLA)
Other REC Limits:NONE RECOMMENDED
Ingred Name:1-PHENYL-3-PYRAZOLIDONE/PYRAZOLIDINONE
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:BASED ON REP-DOSE INGEST ANIMAL
STUDIES 1-PHENYL-3-PYRAZOLIDINONE(COMPO)MAY CAUSE
BLOOD,TESTICULAR,ADVERSE REPROD EFFECTS.ACETIC ACID.ACUTE OVEREXPO
TO EXT HI AIRBORNE CONC ORE RESP IRRIT HAS BEEN ASS OC W/DVLPMT OF
ASTHMALIKE REACTIVE AIRWAYS SYNDROME(RADS)IN SUSCEPTIBLE
INDIVIDUALS.EXT HI AIRBORNE CONC NOT (SIGN/SYMP)
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY
CLASSIFICATION:IARC/ACGIH/NTP/OSHA:NONE.
Effects of Overexposure:HEALTH:GENERATED DURING NORMAL CONDITIONS OF
USE BUT MAY OCCUR FOLLOWING SPILL WHICH DEPENDS ON PHYS
FACTORS(SOLN CONC,SPILL VOL,SURF AREA,RM SIZE,VENTI RATE).INHAL:VAP
EXT IRRIT.EYE:CAUSES SEVERE BUR NS.VAP EXT IRRIT.SKIN:CAUSES SEVERE
BURNS.MAY CAUSE ALLERGIC SKIN RX.INGEST:FATAL/HARMFUL.MAY CAUSE
BURNS OF GI TRACT.
Medical Cond Aggravated by Exposure:FFACUTE OVEREXPO TO EXTREMELY HIGH
AIRBORNE CONCEN OF RESPIRATORY IRRIT HAS BEEN ASSOC W/DVLPMT OF
ASTHMALIKE REACTIVE AIRWAYS SYNDROME(RADS)IN SUSCEPTIBLE
INDIVIDUALS.
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR.BREATH DIFF GIVE OXY;NOT BREATH GIVE
ART RESP.GET MED ATTN IMMED.SKIN:IMMED FLUSH W/PLENTY OF H2O WHILE
REMVOE CONTAM CLOTH/SHOES.GET MED ATTN.INGEST:DO NOT INDUCE
VOMITING.GIV E VICTIM GLASS OF H2O.NEVER GIVE ANYTHING BY MOUTH IF
UNCONSC.CALL DR/POIS CNTRL CNTNR IMMED.
* Fire Fighting Measures *
Flash Point Method:SCC
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NP
Upper Limits:NP
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE (CO2), DRY CHEMICAL,
ALCOHOL FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAIN BREATH APPARATUS & PROT
CLOTH.FIRE/EXCESSIVE HEAT MAY PRODUCE HAZARDOUS DECOMPOSTION
PRODUCTS.USE H2O SPRAY TO KEEP FIRE-EXPO CNTNRS COOL.
Unusual Fire/Explosion Hazard:CLASSIFIED AS COMBUSTIBLE.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL IGN SOURCES.ABSORB SPILL
W/VERMICULITE OR OTHER INERT MATL, THEN PLACE IN CONTAINER FOR
CHEMICAL WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DONT GET IN EYE/SKIN/CLOTH.DONT BREATH
VAP @CONC >EXPO LIMITS.USE ONLY W/ADEQU VENTI.KEEP FROM CONTACT
W/OXIDIZ MATLS.KEEP AWAY FROM HEAT/FLAME.
Other Precautions:KEEP CNTNR CLSD,AWAY FRM INCOMPAT SUBST.STRONGLY
ACIDIC AQUA SOLN.PROPTIES:HI BIOCHEM OXY DEMAND,POT TO CAUSE OXY
DEPLETION IN AQU SYS,HI POT TO AFFECT SOME AQU ORG,HI POT TO AFFECT
2ND WASTE TREAT MI CRO METAB,HI POT TO AFFECT GERM/(SUPPLE)
* Physical/Chemical Properties *
HCC:F6
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Density:1.7
pH:<1.0
Viscosity:NP
Evaporation Rate & Reference:NP
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, ORANGE COLOR, PUNGENT ODOR
Corrosion Rate:NP
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, BASES, AMINES, METALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HAZ COMBUST PROD:CARBON DIOXIDE,CARBON
MONOXIDE,OXIDES OF NITROGEN.HAZ DECOMP PRODS:NONE SPECIFIED BY
MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:DISCH/TREAT/DISPO MAY BE SUBJ TO NAT/STATE/LOC
LAWS.SINCE EMPT CNTNR RETAIN PROD RESIDUE FOLLOW LABEL WARNS EVEN
AFT CNTNR EMPTIED.CONTRACT W/LIC CHEM DISPO AGENCY.CHEM SUBJ TO
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
* First Aid Measures *
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR. AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UN CONSCIOUS PERSON VOMIT.
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
* Physical/Chemical Properties *
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
* Stability and Reactivity Data *
STRONG OXIDIZERS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
Control Measures
*
Product ID: ARGON, G-6
*
Contractor Summary
*
Box: UNKNOW
*
Ingredients
*
OSHA PEL: N/K (FP N)
ACGIH TLV: ASPHYXIANT
------------------------------
AFFECTED AREAS W/LUKEWARM WATER. DO NOT USE
-----------------------------
RSLTED IN BLISTERING OF DERM SURF/DEEP
-----------------------------
-----------------------------
AS FROSTBITE. CONSULT MD FOR TREATMENT.
-----------------------------
FLOW INTO CYL. PROT CYLS FROM PHYSICAL
-----------------------------
AWAY FROM HEAVILY TRAFFICKED AREAS &
-----------------------------
SHOULD BE STORED UPRIGHT & FIRMLY
-----------------------------
OUT" INVENTORY SYS TO PVNT FULL CYLS BEING
-----------------------------
CYL/CNTNR OF GAS IN CRYOGENIC LIQ FORM
-----------------------------
RSLT IN FIRE, EXPLO, ASPHY/TOX EXPOS.
-----------------------------
COMPRESSED GAS CYLS SHOULD NOT BE REFILLED
-----------------------------
COMPRESSED GAS CYL, WHICH HAS NOT BEEN
-----------------------------
-----------------------------
BULLETIN SB-2.
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL:ARGON IS SIMPLE ASPHY. MAINTAIN OXYG LEVELS
IN AIR NEC FOR LIFE MAY INCLUDE ANY, ALL/NONE OF FOLLOWING:TINGLING OF TONGU
E, FINGERTIPS/TOES; WEAKENED SPEECH LEADING TO INABILITY TO UTTER SOUNDS,
RAPID REDUCTION IN ABILITY (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZS:TO PERFORM MOVEMENTS; LOSS OF
TACTILE SENSATIONS; HEIGHTENED MENTAL ACTIVITY. THESE SYMPS MAY/MAY NOT BE
PRESENT SINCE THERE ARE NO DEFINITE SYMPS OF EXPOS. ARGON IS NONTOX BUT
LIBERATION OF LG AMT IN CONFINED AREA COULD DISPLACEAMT OF OXYG IN AIR NEC
TO SUPPORT LIFE. SKIN:FROSTBITE EFTS APPEAR AS (SUP DAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL:PROMPT MED ATTN IS MANDATORY IN ALL CASES OF OVEREXP. RESCUE
PERS SHOULD BE EQUIPPED W/NIOSH/MSHA APPRVD SCBA. CONSCIOUS PERSONS SHOULD BE
ASSISTED TO AN UNCONTAM AREA & INHAL FRESH AIR. QUICK R EMOVAL FROM
CONTAM AREA IS MOST IMPORTANT. UNCON PERSONS SHOULD BE MOVED TO AN UNCONTAM
AREA, GIVEN ARTF RESUSCITATION & SUPP OXYG. FURTHER TREATMENT SHOULD BE
SYMPTOMATIC & SUPPORTIVE.
*
Handling and Disposal
*
Spill Release Procedures: EVACUATE ALL PERS FROM AFFECTED AREAS. USE APPROP
PROT EQUIP. IF LEAK IS IN USER'S EQUIP, BE CERTAIN TO PIPING W/INERT GAS
PRIOR TO ATTEMPTING REPAIRS. IF LEAK IS IN CNTNR/CNTNR VALVE, CONT CHEMTREC F
OR EMER ASSISTANCE/CALL CLOSEST MFR LOCATION.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). DO NOT ATEMPT TO DISPOSE OF WASTE/UNUSED QTYS. RETURN IN
SHIPPING CNTNR PROPERLY LBLED, W/ANY VALVE OUTLET PLUGS/CAPS SECURED &
VALVE PROT CAP IN PLACE TO MFR FOR PROPER DISP.
Handling And Storage Precautions: USE ONLY IN WELL-VENT AREAS. VALVE PROT CAPS
MUST REMAIN IN PLACE UNLESS CNTNR IS SECURED W/VALVE PROT OUTLET PIPED TO USE
POINT.
Other Precautions: DO NOT DRAG, SLIDE/ROLL CYLS. USE SUITABLE HAND TRUCK FOR
CYL MOVEMENT. USE PRESS REDUCING REGULATOR WHEN CONNECTING CYL TO LOWER PRESS
DISCHARGE RATE OF PROD FROM
*
Fire and Explosion Hazard Information
*
Flash Point Text: NONE
Extinguishing Media: NONFLAMMABLE, INERT GAS-USE ANY EXTINGUISHING MEDIA WHICH
IS SUITABLE FOR THE SURROUNDING FIRE.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
*
*
Respiratory Protection: A NIOSH/MSHA APPROVED AIRLINE RESPIRATOR WITH FULL FACE
PIECE EQUIPPED WITH AN ESCAPE BOTTLE OR NIOSH/MSHA APPROVED SCBA SHOULD BE
AVAILABLE FOR EMERGENCY USE. OPERATE THIS EQUIPMENT IN THE POSITIVE P RESSURE
DEMAND MODE, PPD!
Ventilation: USE LOC EXHST VENT TO REDUCE CONCS TO W/IN CURRENT SURE LIMS. LAB
TYPE HOOD FOR HNDLG SM/LIMITED QTYS. MAINTAIN
Other Protective Equipment: SAFETY SHOES, EYEWASH, SAFETY SHOWER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: EFTS OF OVEREXP:CHANGE IN COLOR OF SKIN TO GRAY
OR WHITE POSSIBLY FOLLOWED BY BLISTERING AND MAY OCCUR UPON CONT W/LIQ.
EYES:CONT W/LIQ MAY CAUSE TISS FREEZING. INGEST:SINCE PROD IS GAS AT ROOM
TEMP, INGEST IS UNLIKELY. CONT W/LIQ PROD MAYCAUSE FREEZING OF TISS &
SHOULD BE TREATED AS FROSTBITE.
*
Physical/Chemical Properties
*
Solubility in Water: SLIGHT
Appearance and Odor: A COLORLESS GAS. ODORLESS.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: PRODUCT IS AN INERT GAS.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: NONE SPECIFIED BY MANUFACTURER.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Product ID: ARGON, G-6
Company Name: HOLOX LTD
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:INHALATION:ARGON IS SIMPLE ASPHYXIANT. EFFECTS OF
OVEREXPOSURE TO HIGH CONCENTRATIONS SO AS TO DISPLACE OXYGEN IN AIR NECESSARY
FOR LIFE MAY INCLUDE ANY, ALL OR NONE OF FOLLOWING:TINGLING OF TON GUE,
FINGERTIPS/TOES; WEAKENED SPEECH LEADING TO INABILITY TO UTTER SOUNDS, RAPID
REDUCTION IN ABILITY TO PERFORM MOVEMENTS; LOSS OF TACTILE SENSATIONS,
HEIGHTENED MENTAL ACTIVITY. EYES:TISSUE FREEZIN G. CHRONIC:NONE LISTED BY
MANUFACTURER.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:DUST MASK (PAPER, COTTON)
Supplemental Safety and Health
* Product Identification *
Product ID:CHEMFIL/CHEMFIL II
* Composition/Information on Ingredients *
POLYACRYLIC ACID, ACRYLIC RESIN
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NO SPECIFIC EFFECTS EXCEPT
IRRITATION IF EXCESSIVE DUST. SKIN: DRYING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: NO SPECIFIC EFFECTS EXCEPT
IRRITATION IF EXCESSIVE DUSTS. SKIN: DRYING.
* First Aid Measures *
First Aid:EYE: IRRIGATE THOROUGHLY W/WATER & SEEK MED ATT.
* Fire Fighting Measures *
Extinguishing Media:CO2, DRY CHEMICAL, HALON
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP INTO CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:AVOID FOODSTUFFS. STORE IN DRY
SURROUNDINGS.
* Physical/Chemical Properties *
Solubility in Water:REACTS
Appearance and Odor:DENSE OFF WHITE POWDER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER
Stability Condition to Avoid:HIGH MOISTURE
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:ADD SMALL AMOUNT OF WATER & THROW AWAY. CHECK
LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED
Ventilation:NONE
Other Protective Equipment:NONE
Supplemental Safety and Health
NK
* Product Identification *
Preparer's Name:F.C.
* Composition/Information on Ingredients *
Ingred Name:WATER
Fraction by Wt: PROPRIE
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: PROP
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIMETHYL SILOXANE
Fraction by Wt: PROP
Other REC Limits:NONE RECOMMENDED
Ingred Name:2-BUTOXYETHANOL
Fraction by Wt: PROP
Other REC Limits:NONE RECOMMENDED
Ingred Name:2-AMINO ETHANOL
Fraction by Wt: PROP
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3 PPM
ACGIH TLV:3 PPM
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE IRRITATION. INGESTION:
MAY CAUSE GASTRIC DISTRESS & SYSTEMIC INTOXICATION.
Explanation of Carcinogenicity:NO
* First Aid Measures *
First Aid:EYE: FLUSH THOROUGHLY W/WATER UNTIL IRRITATION SUBSIDES. IF
IRRITAITON PERSISTS GET MEDICAL AID. INGESTION: DON'T INDUCE
VOMITING. GIVE WATER. CALL DR.
* Fire Fighting Measures *
Flash Point Method:TOC
Flash Point:NONE TO BOILING
Lower Limits:NOT EST.
Upper Limits:NOT EST.
Unusual Fire/Explosion Hazard:HEATED PRODUCTS MAY LIBERATE TOXIC FUMES.
WEAR SCBA.
* Accidental Release Measures *
Spill Release Procedures:RECONTAINERIZE BY MOPPING, WET VACUUM OR
SUITABLE ABSORBENT. RINSE REMAINING MATERIAL TO DRAINS.
*Handling and Storage *
Other Precautions:KEEP OUT OF REACH OF CHILDREN. FOR SALE, USE, STORAGE
BY SERVICE PERSONNEL ONLY
* Physical/Chemical Properties *
Vapor Pres:AS WATER
Vapor Density:AS WATER
Evaporation Rate & Reference:AS WATER
Solubility in Water:DISPERSES
Appearance and Odor:OPAQUE, THIN, WHITE LIQUID, ALCOHOL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:FOLLOW LOCAL, STATE, FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:OUTDOOR/OPEN AREA-BYR.MINES APPRVD MECH FILTR
RESPIRATTO REMOV AIRB.
Ventilation:DILUTION OR EXHAUST TO KEEP BELOW TLV.
Other Protective Equipment:PREVENT PROLONGED SKN CONTACT TO
CONTAMINATED CLOTHING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ISOBUTYL ACETATE (SARA III)
Ingred Name:TOLUENE (SARA III)
Ingred Name:ISOBUTYL ALCOHOL (SARA III)
Fraction by Wt: <5%
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
Fraction by Wt: <5%
* Hazards Identification *
Effects of Overexposure:INHAL:ANESTH,IRRIT OR RESPIR TRACT,ACUT NERV
SYS DEPRESS CHARACT BY HDACH,DIZZ,CONFUS,UNCONSC,COMA
* First Aid Measures *
First Aid:IN CASE OF CONTACT,FLUSH SKIN & EYES W/PLENTY OF WATER WHILE
REMOVE CONTAMINAT CLOTHING.IF INHALED. REMOVE TO FRESH AIR.CALL A
DR IF SYMPTOMS PERSIST.
* Fire Fighting Measures *
Extinguishing Media:CL B EXTING (CO*2,DRY CHEMIOR ALCOHOL FOAM.POLYMR
FOAM-LG FI
Fire Fighting Procedures:SELF-CONTAINED BREATH APPARAT AVAIL
F/FIREMEN.WATR MAY BE IN
Unusual Fire/Explosion Hazard:CONTNRS TIGHTLY CLOSE.ISOLAT FR
HEAT,ELECTR EQPMT,SPARKS & OPEN FLAME.DO NOT APPLY TO VERY HOT
SURFA
* Accidental Release Measures *
Spill Release Procedures:REMOV ALL SOURCES OF IGNIT(FLAMES,HOT
SURFACES, AND ELECTRICAL,STATIC,OR FRICTIONAL SPARKS).AVOID
BREATHING VAPORS.VENTILATE AREA.REMOV W/INERT ABSORBENT &
NON-SPARKING TOOLS
*Handling and Storage *
Other Precautions:GROUND CONTNRS WHEN POURING.AVD FREE FALL OF LIQD IN
EXCES OF FEW INCH.DO NOT FLAM CUT,BRAZE OR WELD COATED MATERIAL W/O
BUR OFOF MINES APPRVD RESPIRAT OR APPROP VENTIL.ADD LABEL WARN.DO
NOT T
* Physical/Chemical Properties *
HCC:F2
Vapor Density:HEAV
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FIRES,HEAT, & HOT SURFACES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORD W/LOCAL,STATE,& FEDERAL
REGULATIONS. INCINERATE IN APPRVD FACILITY.DO NOT INCINERATE CLOSED
CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE APPROVED RESPIRATORY PROTECTIVE EQUIPMENT
FOR CLEANING LARGE SPILLS OR ENTRY INTO LARGE TANKS,VESSELS OR
OTHER CONFINED SPACES.
Ventilation:PROVIDE ADEQUATE VENTILATION TO KEEP MIST OR VAPORS BELOW
ALLOWABLE EXPOSURE LEVELS.
Supplemental Safety and Health
* Product Identification *
Product ID:DIESEL FUEL 2
Preparer's Name:DELNO MALZAHN,CIH
* Composition/Information on Ingredients *
Ingred Name:COMPLEX MIXTURE OF PARAFFINIC,OLEFINIC, NAPHTHENIC AND
AROMATIC HYDROCARBONS
OSHA PEL:5 AS OIL MIST
ACGIH TLV:5
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED AND REPEATED SKIN CONTACT
MAY CAUSE DERMATITIS.
Effects of Overexposure:MODERATELY IRRITATING TO SKIN.CAUSES REDNESS
AND DRYING OF SKIN.IRRITATING TO MUCOUS MEMBRANES AND RESPIRATORY
TRACT.WILL PRODUCE SYMPTOMS OF INTOXICATION. CAN ACT AS A SIMPLE
ASPHYXIANT.INGESTION MAY CAUSE MILD EXCITATION,LOSS OF
CONSCIOUSNESS,CONVULSIONS,CYANOSIS,CONGESTION AND CAPILLARY
HEMORRHAGING OF LUNGS/ORGANS.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE PRE-EXISTING
DERMATITIS.
* First Aid Measures *
SKIN,REMOVE CONTAMINATED CLOTHING,WASH WITH SOAP & WATER.IF
INHALED,MOVE TO FRESH AIR.APPLY ARTIFICIAL RESPIRATION IF NOT
BREATHING.GET MEDI CAL ATTENTION.IF INGESTED,DO NOT
INDUCEVOMITING.IF SPONTANEOUS VOMITING OCCURS,HOLD VICTIM'S HEAD
LOWER THAN HIPS TO PREVENT ASPIRATION.
* Fire Fighting Measures *
Lower Limits:0.6
Upper Limits:7.5
Extinguishing Media:DRY CHEMICAL,FOAM,CARBON MONOXIDE,WATER SPRAY.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR SELF-CONTAINED
BREATHING APPARATUS.DO NOT USE A FORCE STREAM OF WATER DIRECTLY ON
OIL FIRES AS THIS WILL SCATTER THE FIRE.
Unusual Fire/Explosion Hazard:CAN BE IGNITED BY SELF-GENERATED STATIC
ELECTRICIT;CONTAINERS SHOULD BE BONDED AND GROUNDED.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF HEAT OR IGNITION,INCLUDING
INTERNAL COMBUSTION ENGINES AND ROWER TOOLS.CLEAN-UP SPILL BUT DO
NOT FLUSH TO SEWER OR SURFACE WATER.VENTILATE AREA AND AVOID
BREATHING VAPORS OR MISTS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS IN
COOL,DRY PLACE,AWAY FROM SOURCES OF HEAT OR IGNITION.GROUND AND
BOND ALL TRANSFER & STORAGE EQUIP WITH SELF CL.
Other Precautions:CONTACT BELCHER COMPANY FOR FURTHER INFORMATION.
* Physical/Chemical Properties *
Vapor Density:8 AIR=1
Solubility in Water:INSOLUBLE
Appearance and Odor:MILD PETROLEUM ODOR,CLEAR TO LIGHT AMBER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT,SPARKS,FLAME,BUILD-UP OF STATIC
ELECTRICITY.
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON DIOXIDE AND
HYDROCARBONS AND SULFUR DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE THROUGH A LICENSED WASTE DISPOSAL
COMPANY.FOLLOW FEDERAL,STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
Control Measures
*
Cage: 0FTL5
Proprietary Ind: Y
*
Preparer Co. when other than Responsible Party Co.
*
Cage: 0FTL5
*
Contractor Summary
*
Cage: 0FTL5
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: MAY CAUSE BURNING & IRRITATION. SKIN: MAY CAUSE
IRRITATION/DERMATITIS. INGESTION: MAY CAUSE IRRITATION.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, BURNING, HEADACHE, DIZZINESS,
DROWSINESS, NAUSEA, GASTRIC DISTURBANCE.
Medical Cond Aggravated By Exposure: SOME SKIN DISORDERS SUCH AS DERMATITIS.
& WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN AL L CASES.
*
Handling and Disposal
*
Spill Release Procedures: WIPE UP W/RAGS. DISPOSE OF RAGS IN CONTAINERS
APPROVED FOR OILY WASTE.
Waste Disposal Methods: DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS..
Handling And Storage Precautions: KEEP CONTAINERS CLOSED WHEN NOT IN USE. KEEP
AWAY FROM EXCESSIVE HEAT, SPARKS, OPEN FLAMES. FOR COMMERCIAL/INDUSTRIAL USE
ONLY.
Other Precautions: DON'T REUSE CONTAINER. KEEP FROM REACH OF CHILDREN.
*
Fire and Explosion Hazard Information
*
Flash Point Method: PMCC
Extinguishing Media: FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE, BUT CAN BE USED TO COOL
CONTAINERS EXPOSED TO HEAT/FLAME. FOG NOZZLES ARE PREFERABLE IF WATER IS
USED.
Unusual Fire/Explosion Hazard: DENSE SMOKE MAY BE GENERATED WHILE BURNING.
*
*
Respiratory Protection: NOT NORMALLY REQUIRED.
Ventilation: GENERAL AS PER LOCAL REGULATIONS.
Other Protective Equipment: APRON, BOOTS, IMPERVIOUS CLOTHING
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
*
Physical/Chemical Properties
*
Vapor Pres: 0.1
Vapor Density: >1
Spec Gravity: <1
Solubility in Water: INSOLUBLE
Appearance and Odor: PURPLE PASTE W/OILY ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: EXCESS HEAT, SPARKS, OPEN FLAME.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: BY FIRE: DENSE SMOKE & CO.
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Cage: 0FTL5
Company Name: AM MULTIGRAPHICS
Label Required IND: Y
Status Code: C
Origination Code: G
Hazard And Precautions: EYES: BURNING & IRRITATION. SKIN:
PROLONGED/REPEATED EXPOSURE MAY CAUSE IRRITATION/DERMATITIS. INGESTION:
IRRITATION. MAY AFFECT THE CNS & RESPIRATORY SYSTEM.
BURNING,
IRRITATION, HEADACHE, DIZZINESS, DROWSINESS, NAUSEA, GASTRIC DISTURBANCE.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA-APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . OTHER PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ETHYL ALCOHOL (ETHANOL)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE FATAL IF INHALED,
SWALLOWED, OR ABSORBED THROUGH SKIN. VAPOR OR MIST IS IRRITATING TO
THE EYES, MUCOUS MEMBRANES AND UPPER RESPIRATORY TRACT. CAUSES SKIN
IRRITATION. CAN CAUSE CNS DEPRES SION. EXPOSURE CAN CAUSE: DAMAGE
TO THEEYES, NAUSEA, DIZZINESS AND HEADACHE. CHRONIC: DAMAGE TO THE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:LIVER. DAMAGE TO THE HEART. DAMAGE TO
THE KIDNEYS. TARGET ORGANS(S): NERVES, EYES, LIVER, KIDNEYS.
ADDITIONAL INFORMATION: WARNING: CONTAINS METHANOL. MAY BE FATAL OR
CAUSE BLINDNESS IF SWALL OWED. CANNOT BE MADE NONPOISONOUS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:EYES OR SKIN: FLUSH IMMED W/COPIOUS AMOUNTS OF H*2O FOR AT
FLUSHING OF EYES BY SEPARATING THE EYELIDS W/FINGERS. INHAL: REMOVE
TO FRES H AIR. IF NOT BREATHING GIVE ARTIFICIALRESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. INGEST: WASH OUT MOUTH WITH
WATER PROVIDED PERSON IS CONSCIOUS. CALL MD. WASH CONTAMD CLTHG
BEFORE REUSE.
* Fire Fighting Measures *
Upper Limits:3.3%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR APPROPRIATE
FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS.
WARNING: FLAMMABLE LIQUID.
Unusual Fire/Explosion Hazard:VAPOR MAY TRAVEL CONSIDERABLE DISTANCE TO
SOURCE OF IGNITION AND FLASH BACK.
* Accidental Release Measures *
Spill Release Procedures:SHUT OFF ALL SOURCES OF IGNITION. EVACUATE
SAND/VERMICULITE & PLACE IN CLOSED CONTAINERS FOR DISPOSAL. USE
NONSPARKING TOOLS. VENT AREA & WASH SPILL SITE AFTER MATRL PICKUP
IS COMPLETE.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL DRY PLACE. KEEP
TIGHTLY CLOSED. KEEP AWAY FROM HEAT, SPARKS, AND OPEN FLAME.
POISON. IRRITANT. DO NOT BREATHE VAPOR.
Other Precautions:DO NOT GET IN EYES, ON SKIN, ON CLOTHING. AVOID
PROLONGED OR REPEATED EXPOSURE. CANNOT BE MADE NON-POISONOUS. NO
SMOKING.
* Physical/Chemical Properties *
Appearance and Odor:LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, PEROXIDES, ACIDS, ACID CHLORIDES, ACID ANHYDRIDES,
ALKALI METALS, AMMONIA, MOISTURE.
Stability Condition to Avoid:
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER BUT EXERT EXTRA CARE IN IGNITING AS THIS
MATERIAL IS HIGHLY FLAMMABLE. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGUL ATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED UNDER NORMAL USE.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:AVOID INHALATION, INGESTION, SKIN OR EYE
CONTACT.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:IRON (III) OXIDE
ACGIH TLV:5 MG(FE)/M3 FUME, B2
Ingred Name:CALCIUM OXIDE
Fraction by Wt: 1%
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
Fraction by Wt: 5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COPPER OXIDE; (COPPER OXIDES)
OSHA PEL:1 MG CU/M3
ACGIH TLV:1 MG CU/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:NONE IN NORMAL HANDLING AND USE.
SIGNS AND SYMPTOMS OF EXPOSURE:MINIMAL RESPIRATORY TRACT IRRITATION
MAY OCCUR AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY NON-TOXIC DUST.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT APPLICABLE.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . SKIN:WASH WITH SOAP AND WATER. EYE:FLUSH THOROUGHLY WITH
INGEST:DILU TE STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER AND
SEEK MEDICAL TREATMENT.
* Fire Fighting Measures *
Extinguishing Media:IF PRODUCT BECOMES INVOLVED IN A FIRE USE CARBON
DIOXIDE EXTINGUISHER. WATER, FOAM OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE UNDER NORMAL STORAGE AND USE
CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:CLEAN UP WITH A VACUUM CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:CLOSE CAP TIGHTLY AND STORE IN A COOL,
DRY AND DARK PLACE.
Other Precautions:AVOID COMBUSTION.
SOL IN H*2O:INSOLUBLE/NEGLIGIBLE (TOLUENE).
* Physical/Chemical Properties *
Solubility in Water:SUPP DATA
Appearance and Odor:FINE BLACK POWDER, PRACTICALLY ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE IN NORMAL HANDLING AND USE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH.
Ventilation:LOCAL EXHAUST PREFERABLE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
CAGE:ACEHA
CAGE:ACEHA
* Composition/Information on Ingredients *
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS)
Ingred Name:ALUMINUM HYDROXIDE
Fraction by Wt: 1.1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CARBON BLACK
Fraction by Wt: 0.6%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:NEPHELINE SYENITE
OSHA PEL:N/K
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Ingred Name:SILICA, AMORPHOUS FUMED; (AMORPHOUS SILICA)
Fraction by Wt: 2.4%
OSHA PEL:6 MG/M3
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE; (CRYSTALLINE SILICA)
Fraction by Wt: <0.1%
Ingred Name:IRON (III) OXIDE; (RED IRON OXIDE)
Fraction by Wt: 5%
ACGIH TLV:5 MG/M3 FUME (FE)
Ingred Name:IRON HYDROXIDE OXIDE; (HYDRATED IRON OXIDE)
Fraction by Wt: 3.1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CARBAMIC ACID, BUTYL-,3-IODO-2-PROPYNYL ESTER;
(3-IODO-2-PROPYNL BUTYLCARAMATE)
Fraction by Wt: 0.3%
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM MAY OCCUR ON OVEREXPOSURE. MAY ALSO CAUSE
NERVOUS SYSTEM DEPRESSION. CHRONIC: REPORTS HAVE ASSOCIATED
REPEATED AND PROLONGED OCCUPATIONAL OVEREXP OSURE TO SOLVENTS WITH
PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:CARBON BLACK: IARC MONOGRAPHS ON THE
Effects of Overexposure:HEADACHE, DIZZINESS, NAUSEA AND LOSS OF
COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO VAPORS OR
SPRAY MISTS.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE FROM EXPOSURE.
RESTORE BREATHING. KEEP WARM AND QUIET. SKIN: IF ON SKIN, WASH
AFFECTED AREA THOROUGHLY WITH SOAP AND WATER. EYES: IF IN EYES,
GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:0.9%
Extinguishing Media:FOR DRY SOLIDS, USE WATER, FOAM, CARBON DIOXIDE,
DRY CHEMICALS.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP. WATER
MAY BE USED TO COOL CLSD CNTNRS TO PVNT PRESS BUILDUP & POSS
AUTOIGNIT OR EXPLO WHEN EXPOS TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLOSED. ISOLATE FROM
HEAT, ELECTRICAL EQUIP, SPARKS & OPEN FLAME. HEAT MAY CAUSE PRESS
BUILDUP IN CLOSED CNTNRS. WATER MAY BE USED TO COOL.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:CONTENTS ARE COMBUST. KEEP AWAY FROM
HEAT & OPEN FLAME. USE APPRVD BONDING & GROUNDING PROCEDURES.
TRANSFER ONLY TO APPROVED, PROPERLY MARKED CNTNRS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. INTENTIONAL MISUSE BY
DELIBERATELY INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER/ETHER
Appearance and Odor:COLORED PIGMENTED LIQUID WITH SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH APPROVED ORGANIC VAPOR CARTRIDGE
RESPIRATOR WHEN VAPOR/MIST EXPOSURE IS LIKELY.
Ventilation:GENERAL MECHANICAL & LOCAL EXHAUST.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
KEEP CONTAINER CLOSED. USE W/ADEQUATE VENTILATION. KEEP AWAY FROM
HEAT/SPARKS/FLAME.
* Product Identification *
Preparer's Name:M MUNSELL
* Composition/Information on Ingredients *
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
Ozone Depleting Chemical:2
Ingred Name:HEPTANE
Ingred Name:HYDROCARBON PROPELLANT, PETROLEUM GASES LIQUEFIED
Ingred Name:POLY(DIFLUOROMETHYLENE),
ALPHA-(CYCLOHEXYMETHYL)-OMEGA-HYDRO
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: ASPHYXIATION. CHRONIC:
HIGH VAPOR CONCENTRATION MAY LEAD TO LUNG, KIDNEY, LIVER DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DIZZINESS, WEAKNESS, ASPHYXIATION, NARCOSIS,
DEFATTING.
Medical Cond Aggravated by Exposure:SKIN & EYE CONDITIONS.
* First Aid Measures *
W/SOAP & WATER. INGESTION: IF CONSCIOUS, GIVE PLENTY OF WATER TO
DRINK. DON'T INDUCE VOMITTING. INHALATION: REMOVE TO FRESH AIR.
GIVE CPR/OXYGEN IF NEEDED. OBTAIN MEDICAL ATTENTION INALL CASES.
* Fire Fighting Measures *
Lower Limits:1.3
Upper Limits:9.5
Extinguishing Media:CO2, DRY CHEMICAL, FOAM/WATER.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:AEROSOLS MAY BURST IF EXPOSED TO TEMPS
* Accidental Release Measures *
Spill Release Procedures:REMOVE BY ABSORBING IN ABSORBANT MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:EXTREMELY FLAMMABLE. CONTENTS UNDER
PRESSURE. VAPOR/GAS REDUCES OXYGEN AVAILABLE FOR BREATHING. STORE
Other Precautions:DON'T PUNCTURE/INCINERATE CONTAINER. DON'T ENTER
STORAGE AREAS UNLESS ADEQUATELY VENTILATED.
* Physical/Chemical Properties *
Vapor Pres:(SEE SUPP)
Vapor Density:>1
Evaporation Rate & Reference:(WATER=1): >1
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR LIQUID W/MILD HYDROCARBON ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALI/ALKALINE EARTH METALS.
Stability Condition to Avoid:DIRECT SUNLIGHT & OTHER HEAT SOURCES.
Hazardous Decomposition Products:CO, CO2, HYDROGEN FLUORIDE, CARBONYL
HALIDES, HYDROCHLORIC & HYDROFLUORIC ACIDS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:UNLESS AIR MONITORING DEMONSTRATES VAPOR/MIST
LEVELS ABOVE APPLICABLE LIMITS, NO RESPIRATOR IS REQUIRED. IF
RESPIRATOR IS REQUIRED, THE APPROPRIATE, PROPERLY FITTED RESPIRATOR
(NIOSH APPROVED) SHOULD BE WORN DURING APPLICATION. FOLLOW
RESPIRATOR MANUFACTURERS DIRECTIONS FOR RESPIRATOR USE.
Ventilation:REQUIRED WHEN SPRAYING OR APPLYING IN CONFINED AREA.
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . USUAL CLOTHING FOR PAINTING OPERATIONS.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:REGULATORY AFFAIRS DEPT
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS INGREDIENTS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF INHALED. MAY AFFECT
THE BRAIN, NERVOUS SYSTEM OR RESPIRATORY SYSTEM, CAUSING DIZZINESS,
HEADACHE, NAUSEA OR RESPIRATORY IRRITATION. OVEREXPOSURE TO
INGREDIENTS IN THIS PRODUCT MAY CA USE EYE IRRITATION. DELAYED
EFFECTS (CHRONIC): NONE KNOWN.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ANY RESPIRATORY OR SKIN CONDITION.
* First Aid Measures *
First Aid:NONE. INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH
AIR. SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) . EYES:
ASSISTANCE FROM MD . SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. .
* Fire Fighting Measures *
Flash Point Method:TCC
SUPDAT
Lower Limits:2.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, AND/OR WATER
FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . CONTAINERS EXPOSED TO FIRE SHOULD BE KEPT COOL WITH
WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. REMOVE SPILLS WITH INERT
ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUE. DO NOT CUT, PUNCTURE
OR WELD CONTAINERS. ALL LABEL WA RNINGS MUST BE OSBERVED UNTIL
CONTAINER HAS BEEN CLEANED, RECONDITIONED OR PROPERLY DISPOSED OF.
* Physical/Chemical Properties *
Vapor Density:7.4(AIR=1)
VOC Grams/Liter:2.6
Evaporation Rate & Reference:0.4 (BUTYL ACETATE =1)
Solubility in Water:YES
Appearance and Odor:NORMAL FOR A COATINGS PRODUCT.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID WATER-REACTIVE MATERIALS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CARBON DIOXIDE/MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN CHEMICAL DISPOSAL AREA OR IN A MANNER
THAT COMPLIES WITH LOCAL, STATE, PROVINCIAL AND FEDERAL
REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
* Regulatory Information *
PRODUCT.
Federal Regulatory Information:ALL COMPONENTS OF THIS PRODUCT ARE IN
COMPLIANCE WITH U.S. TSCA CHEMICAL SUBSTANCE INVENTORY
REQUIREMENTS. NO HAZARDOUS CHEMICALS PRESENT.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN WELDING IN CONFINED SPACE OR WHERE LOCAL EXHAUST OR
VENTILATION DO NOT KEEP EXPOSURE BELOW TLV.
Ventilation:VENT, LOCAL EXHST, TO KEEP BELOW TLV'S IN WORKER'S BRTHG
ZONE. FOR MORE SPECIFIC INFORMATION CONTACT NEHC .
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
FOR MORE SPECIFIC INFORMATION CONTACT NEHC .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
APPEAR/ODOR:BONDED FLUXES ARE AGGIOMERATED MINERAL & ALLOY PARTICLES,
ODORLESS. EXTING MEDIA:FOR BURNING MATLS & FIRE SITUATION. HAZ
DECOMP PROD:WORKED, PROCESS, PROC & CONSUMABLES USED. OTHER CNDTNS
WHICH ALSO INFLUENCE COMPOSITION & QTY OF FUMES & GASES TO WHICH
WORKERS MAY BE EXPOSED INCLUDE:COATINGS ON (ING 9)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SIO2)
OSHA PEL:SEE TABLE Z-3
Ingred Name:MAGNESIUM OXIDE; (MG*O)
Ingred Name:TITANIUM OXIDE; (TIO*2)
Ingred Name:ZIRCONIUM; (ZRO*2)
OSHA PEL:5 MG/M3
Ingred Name:SILICIC ACID (H*2SIO*3), DISODIUM SALT; (SILICATE BINDER)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CALCIUM FLUORIDE; (FLUORSPAR- FLUORIDES INCLUDING #8)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM FLUOALUMINATE; (FLUORIDES)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:MATL BEING WORKED (SUCH AS PAINT,
PLATING/GALVANIZING), NUMBER OF WELDING OPERATIONS & VOLUME OF WORK
Ingred Name:ING 9:AREA, QUALITY & AMT OF VENT, POSITION OF WORKERS HEAD
Ingred Name:EFTS OF OVEREXP:PROPORTIONAL TO LENGTH OF EXPOS. CHANGES
INFORMATION CONTACT NEHC .
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: GASES, FUMES & DUSTS MAY INCL
IRRIT OF EYES, LUNGS, NOSE & THROAT. SOME TOX GASES ASSOCD
W/WELDING MAY CAUSE PULM EDEMA, ASPHY, & DEATH, ACUTE OVEREXP MAY
INCL SIGNS & SYMPS SUCH AS WATERY EYES , NOSE & THROAT IRRIT,
HDCHS, DIZZ, DFCLT IN BRTHG, FREQUENT COUGHING/CHEST PAIN. DUST
GENERATED (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC MONO,
BE CARCIN.
Effects of Overexposure:HLTH HAZ:FROM POURING/OTHERWISE HNDLG FLUX MAY
ALSO CAUSE IRRIT OF EYES, LUNGS, NOSE & THROAT. INGEST OF BARIUM
OXIDES CAN RSLT IN SEV PAIN, VOMIT, PARALYSIS & DEATH. CHRONIC:TO
AIR CONTAMS MAY LEAD T O THEIR ACCUMULATION IN LUNGS, CNDTN WHICH
MAY BE SEEN AS DENSE AREAS ON CHEST X-RAYS. SEVERITY OF CHANGE IS
Medical Cond Aggravated by Exposure:INDIVIDUALS W/ALLERGIES/IMPAIRED
RESP FUNCTION MAY HAVE SYMPS WORSENED BY EXPOS TO WELDING FUMES.
HOWEVER, SUCH RXN CANNOT BE PREDICTED DUE TO VARIATION IN
COMPOSITION & QUANTITY OF THE DECOMP PRODS.
* First Aid Measures *
First Aid:IN CASE OF EMER, CALL FOR MED AID. EMPLOY FIRST AID
TECHNIQUES REC BY THE RED CROSS. INGEST:CALL MD IMMED . EYES:IMMED
SKI N:FLUSH W/COPIOUS AMTS OF H*2O. CALL MD. INHAL:IF BRTHG IS
DFCLT, GIVE OXYGEN & CALL FOR MD. FOR ELECTRIC SHOCK, DISCONNECT &
TURN OFF POWER. FOR MORE SPECIFIC INFORMATION CONTACT NEHC .
* Fire Fighting Measures *
Extinguishing Media:THIS PROD WILL NOT BURN, HOWEVER, WELDING ARCS &
SPARKS CAN IGNITE COMBUST & FLAMM MATLS. USE EXTING MEDIA REC
(SUPDAT)
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:READ AND UNDERSTAND THE MANUFACTURER'S
INSTRUCTIONS AND THE PRECAUTIONARY LABEL ON THIS PRODUCT.
WELDING & CUTTING". PUBLISHED BY AMERICAN WELDING SOCIETY, P. O.
* Physical/Chemical Properties *
Appearance and Odor:SOLID; FUSED FLUXES ARE GRANULATED GLASS-LIKE
PARTICLES, ODORLESS. (SUPDAT)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE CURRENTLY KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES & GASES CANNOT BE
CLASSIFIED SIMPLY. COMPOSITION & QTY OF BOTH ARE DEPENDENT UPON
MATL BEING (SUPDAT)
* Disposal Considerations *
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER, OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
WITH FEDERAL, STATE A ND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AS REQUIRED
Ventilation:ADEQUATE
Other Protective Equipment:OPERATING PROCEDURES (SUCH AS BULK TONER
Supplemental Safety and Health
* Product Identification *
CAGE:0E6G9
CAGE:0E6G9
* Composition/Information on Ingredients *
Ingred Name:1,3-BUTADIENE POLYMER, STYRENE-BUTADIENE POLYMER, SBS, SBS
(BLOCK POLYMER)
Ingred Name:COLUMBIA CARBON, CARBON BLACK, LAMPBLACK (SUSPECTED HUMAN
CARCINOGEN BY ACGIH), BLACK PEARLS
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/CUM
ACGIH TLV:3.5 MG/CUM
Ingred Name:RED IRON OXIDE/IRON (III) OXIDE/FERRIC OXIDE/YELLOW FERRIC
OXIDE/METAL OXIDE/YELLOW IRON OXIDE/IRON OXIDE PIGMENT/IRON
Fraction by Wt: <5%
Ingred Name:AMMONIUM, DEMETHYLDIOCTADECYL-, METHYL SULFATE, QUARTERNARY
Fraction by Wt: <2%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:RESPIRATORY TRACT IRRITATION
Explanation of Carcinogenicity:SEE INGREDIENTS
* First Aid Measures *
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. INHALATION:
REMOVE TO FRESH AIR. INGESTION: DILUTE STOMACH CONTENTS W/SEVERAL
GLASSES OF WATER.
* Fire Fighting Measures *
Extinguishing Media:WATER, DRY CHEMICAL, CO2 OR FOAM
Fire Fighting Procedures:AVOID INHALATION OF SMOKE. WEAR PROTECTIVE
CLOTHING & SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. LIKE MOST
ORGANIC MATERIALS IN POWDER FORM, WHEN DISPERSED IN AIR, IT CAN
FORM EXPLOSIVE MIXTURES.
* Accidental Release Measures *
Spill Release Procedures:SWEEP/VACUUM SPILLED TONER & CAREFULLY
TRANSFER INTO SEALABLE WASTE CONTAINER. SWEEP SLOWLY TO MINIMIZE
DUST GENERATION. VACUUM MOTOR MUST BE RATED AS DUST TIGHT. A
CONDUCTIVE HOSE BONDED TO MACHINE S HOULD BE USED TO REDUCE STATIC
BUILDUP.SEE SUPPL.
*Handling and Storage *
Handling and Storage Precautions:USE W/ADEQUATE VENTILATION.
Other Precautions:AVOID INHALATION OF EXCESSIVE DUST.
* Physical/Chemical Properties *
Spec Gravity: 1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER W/FAINT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION MAY BE TOXIC.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. INCINERATE ONLY IN CLOSED CONTAINER.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH/MSHA APPROVED FACE MASK W/ORGANIC
VAPOR CANISTER.
Ventilation:USE ONLY IN WELL VENTILATED AREA.
Other Protective Equipment:NOT APPLICABLE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ACETIMIDIC ACID, THIO-N-((METHYLCARBAMOYL)OXY)-, METHYL
OSHA PEL:2.5 MG/M3
ACGIH TLV:2.5 MG/M3
Ingred Name:OXAMIMIDIC ACID, N',N'-DIMETHYL-N-(METYLCARBAMOYL)OXY)-1-
METHYLTHIO-
Ingred Name:UREA, 1,1-DIMETHYL-3- (ALPHA, ALPHA, ALPHA-
TRIFLUORO-M-TOLYL)-
Ingred Name:CARBAMIC ACID,
RAT) 5.3 MG/KG
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF INHALED. MAY BE FATAL IF
SWALLOWED. CAN CAUSE GASTROINTESTINAL DISTURBANCES & BLINDNESS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HEADACHE & NAUSEA.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
VOLUMES OF WATER. INHAL:IMMED MOVE TO FRESH AIR. IF BREATHING
STOPS, GIVE ARTF RESP. CONTACT MD. INGEST:NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON. NEVER TRY TO MAKE AN UNCONSCIOUS
PERSON VOMIT. GIVE 2 TABLESPOONS OF BAKING SODA IN A GLASS OF
WATER. PRESS FINGERS TO BACK OF TONGUE TO INDUCE VOMITING. CONTACT
MD IMMED.
* Fire Fighting Measures *
Lower Limits:6.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
* Accidental Release Measures *
Spill Release Procedures:TAKE UP W/ABSORBENT MATERIAL. VENTILATE AREA.
ELIMINATE ALL IGNITION SOURCES.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN SEALED CONTAINER IN COOL, DRY
LOCATION. KEEP AWAY FROM OXIDIZERS. KEEP AWAY FROM IGNITION
SOURCES.
Other Precautions:AVOID EYE OR SKIN CONTACT. AVOID BREATHING VAPORS.
* Physical/Chemical Properties *
HCC:F5
Evaporation Rate & Reference:>1 (ETHER=1)
Appearance and Odor:CLEAR COLORLESS LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, CHROMIC ANHYDRIDE, LEAD PERCHLORATE & PERCHLORIC
ACIDS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:NOT APPLICABLE.
* Disposal Considerations *
Waste Disposal Methods:COMPLY W/ALL APPLICABLE FEDERAL, STATE OR LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ORGANIC VAPOR TYPE
Ventilation:GENERAL-MECHANICAL RECOMMENDED.
Other Protective Equipment:AS REQUIRED
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
* Hazards Identification *
Effects of Overexposure:IRRITATES SKIN & EYES.MAY CAUSE SLIGHT
ANESTHESIA,HEADACHES,ETC.
* First Aid Measures *
First Aid:FLUSH WITH WATER.INHALATION-REMOVE TO FRESH AIR.OBTAIN
MEDICAL ATTENTION.
* Fire Fighting Measures *
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:CO*2 OR FOAM
Fire Fighting Procedures:SELF CONTAINED BREATHING APPARATUS &
PROTECTIVECLOTHING WORN
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT MATERIAL TO COLLECT AND CONTAIN
FOR SALVAGE OR DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:PRODUCT IS FLAMMABLE.USE REASONABLE
CARE.
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:F4
Vapor Density:>1
Spec Gravity:0.9
Evaporation Rate & Reference:<1(ETHER)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SOLVENT ODOR,LIQUID,SOME COLOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION
Hazardous Decomposition Products:SIO*2,CO*2,TRACES OF INCOMPLETELY
BURNED CARBON PRODUCTS.
* Disposal Considerations *
Waste Disposal Methods:LANDFILL & INCINERATION RECOMMENDED.ALL
LOCAL,STATE & FEDERAL HEALTH & POLLUTION REGULATIONS BE REVIEWED TO
DETERMINE APPROVED DISPOSAL PROCEDURES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATOR WITH FILTER IF SPRAYED IN ENCLOSED,
UNVENTILATED SPACE.
Ventilation:NONE, UNLESS APPLIED AS SPRAY. USE WHERE VENTILATION WILL
CARRY SPRAY MIST AWAY FROM OCCUPIED AREAS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE
* Product Identification *
Preparer's Name:CHERI A ZELEZNIK
* Composition/Information on Ingredients *
Ingred Name:MINERAL OIL, WHITE
Other REC Limits: RECOMMENDED
Ingred Name:ISOCYLDIPHENYLPHOSPHATE
Other REC Limits: RECOMMENDED
Ingred Name:CASTOR OIL
Other REC Limits: RECOMMENDED
Ingred Name:ISOBUTANE
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: CAN IRRITATE BY REMOVING NATURAL
SKIN OILS ON LONG OR REPEATED EXPOSURES. EYES: IRRITATING. INHAL:
HEATED BULK VAPORS MAY CAUSE DIZZINESS & NAUSEA. INGEST: NOT
SIGNIFICANT IN SMALL (MOUTHFUL) AM OUNTS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:.
* First Aid Measures *
First Aid:SKIN-WASH OFF WITH SOAP AND WATER. USE SOOTHING LOTION.
EYES-RINSE CAREFULLY UNDER UPPER & LOWER EYELIDS USING PLENTY OF
WATER. INHALATION-REMOVE TO FRESH AIR IF DIZZY OR NAUSEATED.
INGESTION-DO NOT I NDUCE VOMITING. ACCIDENTAL INGESTION OFA SMALL
MOUTHFUL IS NOT EXPECTED TO CAUSE SIGNIFICANT HARM. NOTE:IN ALL
SEVERE CASES, CONT PHYICIAN IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
KEEP CNTNR COOL W/WATER SPRAY. DO NOT SPRAY WATER ON BURNING
Unusual Fire/Explosion Hazard:AEROSOL CANS MAY BURST IF HEATED ABOVE
* Accidental Release Measures *
Spill Release Procedures:MOP UP OR SWEEP UP WITH ABSORBANT.
Neutralizing Agent: SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID BREATHING SPRAY MIST. AVOID
REPEATED OR PROLONGED SKIN CONTACT. AVOID EYE CONTACT. STORE AWAY
FROM HEAT SOURCE.
Other Precautions:ECOLOGICAL INFORMATION: IT EMULSIFIES INTO WATER & IS
BIODEGRADABLE. ITS LOW BULK VAPOR PRESSURE MAY EXEMPT IT FROM VOC
RESTRICTIONS. ISOBUTANE PROPELLANT IS NOT AN OZONE DEPLETER.
* Physical/Chemical Properties *
HCC:V5
Vapor Pres:SUPDAT
Vapor Density:HVR/AIR
pH:NEUT
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:0 EMULSIFIES IN H2O
Appearance and Odor:GREEN, OILY LIQUID W/MILD SPICEY ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
.
Stability Condition to Avoid: SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WHEN BURNING, SOOT, CARBON & NITROGEN
OXIDES.
* Disposal Considerations *
Waste Disposal Methods:AS A NON-HAZARDOUS OILY WASTE, INCINERATE OR
SEND TO WASTE HANDLER WHO CAN BLEND IT INTO SECONDARY FUELS. RCRA:
NOT A HAZARDOUS WASTE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE SUPPLIED-AIR RESPIRATORY PROTECTION IN
CONFINED OR ENCLOSED SPACES, IF NEEDED.
Ventilation:SUFFICIENT TO MAINTAIN ATMOSPHERE BELOW TLV LIMIT.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. CHEMICALLY
RESISTANT BOOTS AND APRONS RECOMMENDED.
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID SKIN CONTACT.
WASH SKIN AFTER USING PRODUCT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health
WASH OR TAKE SHOWER IF GENERAL CONTACT OCCURS. REMOVE OIL-SOAKED
CLOTHING AND LAUNDER BEFORE REUSE. DISCARD CONTAMINATED LEATHER
GENERATED,OBSERVE A TWA/PEL OF 5 MG/M3 FOR MINERAL OIL MIST.
* Product Identification *
Product ID:SCT ARTIC OIL HD
* Composition/Information on Ingredients *
Ingred Name:LUBRICATING OIL BASE STOCK
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 OIL MIST
ACGIH TLV:5 MG/M3 OIL MIST
Ingred Name:DIALKYLDITHIOPHOSPHORIC ACID, ZINC SALT.
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-INGESTION:IRRITATION OF GI
TRACT. INHALATION:HEATED MIST OR VAPORS MAY CAUSE IRRITATION OF
NOSE & THROAT. MINUTE AMOUNTS ASPIRATED INTO LUNGS MAY CAUSE
PULMONARY INJURY. EYE: IRRITATION. SKIN: I RRITAION.
CHRONIC-PROLONGED/REPEATED SKIN CONTACT MAY CAUSE IRRITATION, AND
DERMATITIS.
Explanation of Carcinogenicity:THE COMPONENTS OF THIS PRODUCT HAVE NOT
SHOWN ANY EVIDENCE OF BEING CARCINOGENIC.
Effects of Overexposure:SKIN CONTACT MAY CAUSE SKIN IRRITATION. EYE
CONTACT MAY CAUSE EYE IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH A SKIN DISORDER SHOULD
AVOID PROLONGED CONTACT WHEN HANDLING OR USING THIS PRODUCT.
* First Aid Measures *
First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER.
GET MEDICAL ATTENTION IF IRRITATION PERSISTS. INHALATION: REMOVE TO
FRESH AIR & RESTORE BREATHING IF NECESSARY. GET MEDICAL ATTENTION.
EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION: GET IMMEDIATE
MEDICAL ATTENTION. DO NOT INDUCE VOMITING. NOTHING BY MOUTH IF
UNCONSCIOUS.
* Fire Fighting Measures *
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
* Accidental Release Measures *
Spill Release Procedures:RECOVER FREE PRODUCT, OR ABSORB WITH
DIATOMACEOUS EARTH OR OTHER INERT MATERIAL. STORE IN APPROPRIATE
CONTAINER FOR DISPOSAL. KEEP PRODUCT OUT OF SEWERS AND WATERCOURSES
BY DIKING OR IMPOUNDING. MINIM IZE SKIN CONTACT AND BREATHING
VAPORS.
*Handling and Storage *
Handling and Storage Precautions:AVOID STORAGE NEAR OPEN FLAME OR OTHER
SOURCES OF IGNITION,AND STRONG OXIDANTS.KEEP CONTAINERS CLOSED.
Other Precautions:EMPTY CONTAINERS RETAIN RESIDUE.DO NOT
PRESSURIZE,CUT,WELD OR EXPOSE TO HEAT,FLAME,STATIC ELECTRICITY, OR
OTHER SOURCES OF IGNITION;THEY MAY EXPLODE AND CAUSE INJURY.
* Physical/Chemical Properties *
HCC:V6
Vapor Density:>1
pH:NEUTRL
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK AMBER LIQUID, MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES
Hazardous Decomposition Products:FUMES,SMOKE., OXIDES OF CARBON,
NITRGEN, SULFUR AND ZINC.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHEN NORMAL VENTILATION AVAILABLE.
IF SPRAYING MORE THAN ONE-HALF CAN CONTINUOUSLY, WEAR A NIOSH
RESPIRATOR.
Ventilation:NORMAL ROOM VENTILATION. DON'T USE IN CONFINED AREAS W/NO
VENTILATION
Other Protective Equipment:A SOURCE OF CLEAN WATER SHOULD BE NEARBY IN
CASE OF ACCIDENTAL EYE CONTACT. WEAR LONG PANTS & LONG SLEEVES.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USING & BEFORE
EATING, DRINKING/SMOKING.
Supplemental Safety and Health
FLASHPOINT IS FOR PROPELLANT.
* Product Identification *
Product ID:SPOTBLASTER
CAGE:0FVJ0
* Composition/Information on Ingredients *
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
Ingred Name:2-AMINOETHANOL, ETHANOLAMINE, MONOETHANOLAMINE
Fraction by Wt: <2%
Other REC Limits:3 PPM
OSHA PEL:3 PPM
ACGIH TLV:7.5 MG/CUM
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
Fraction by Wt: <5%
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, CORNEAL INJURY.
SKIN: IRRITATION. 2-BUTOXYETHANOL MAY RESULT IN BLOOD
ABNORMALITIES. CHRONIC EXPOSURE MAY CAUSE SPLEEN & TESTES DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:HEART DISEASE, RESPIRATORY
DISORDERS.
* First Aid Measures *
First Aid:INGESTION: DON'T INDUCE VOMITING. INHALATION: REMOVE TO FRESH
AIR. GIVE CPR/OXYGEN IF NEEDED. EYES: FLUSH IMMEDIATELY W/PLENTY OF
MEDICA L ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER FOG, DRY CHEMICAL, CO2
Fire Fighting Procedures:WATER SHOULD BE USED TO KEEP CONTAINER COOL
* Accidental Release Measures *
Spill Release Procedures:ABSORB EXCESS MATERIAL W/ABSORBENT/RAG.
*Handling and Storage *
Handling and Storage Precautions:USE CAN ONLY IN UPSIDE DOWN POSITION.
CANS. CONTENTS UNDER PRESSURE.
Other Precautions:CONTENTS UNDER PRESSURE. FOR INDUSTRIAL &
INSTITUTIONAL USE ONLY NOT FOR HOUSEHOLD USE/RESALE. KEEP OUT OF
REACH OF CHILDREN.
* Physical/Chemical Properties *
Spec Gravity:0.9
Solubility in Water:COMPLETE
Appearance and Odor:A CLEAR AEROSOL SPRAY W/FRESH CITRUS ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS/ACIDS.
Hazardous Decomposition Products:CO2 & WATER.
* Disposal Considerations *
Waste Disposal Methods:GIVE TO WASTE DISPOSAL COMPANY EQUIPPED TO
HANDLE PRESSURIZED CONTAINERS. DISPOSE OF IAW/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APRPOVED RESP(I.E. AIR-PURIFYING RESP
W/ORGANIC VAP CARTRIDGE) IF VENTI IS INADEQUATE TO CONTROL
MISTS.USE SCBA DURING EMERGENCY RESPONSE ACTIVITIES IF ATMOSPHERE
Ventilation:USE W/ADEQUATE VENTILATION.USE MECHANICAL FAN OR VENT AREA
TO OUTSIDE.
Other Protective Equipment:USE BODY PROTECTION APPROPRIATE FOR
TANK(I.E.TYVEK SUIT,RUBBER APRON).
Work Hygienic Practices:AVOID GETTING CHEM ON YOU/IN YOU.WASH HANDS AFT
HNDLG CHEM.DONT EAT/DRINK WHILE HNDLG PROD.AIM @ELIMINATING ENVIRO
CONTM
Supplemental Safety and Health
FLASH PT/AUTOIGN FOR PROPYLENE GLYCOL. HEALTH:CHRONIC:SYMPT SIMILAR TO
ACUTE EXPO. 1STAID:TAKE COPY OF LABEL/MSDS TO DR/HEALTH PROF
W/VICTIM.DR:TREAT SYMPTOMS.
* Product Identification *
Product ID:PROGARD SPC
CAGE:0NTW1
CAGE:0NTW1
* Composition/Information on Ingredients *
Ingred Name:PROPYLENE GLYCOL
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL-P-HYDROXYBENZOATE; ETHYLPARABEN
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:MIST MAY CAUSE IRRIT
NOSE/THROAT/RESP SYS.EYE:IRRIT,RED.SKIN:IRRIT.SKIN ABSORP:CURRENTLY
NO EVIDENCE WHICH INDICATES MATL COMPO ABSORB THRU SKIN & ENTER
BLOODSTREAM.INGEST:LG DOSES MAY CAUSE GI
DISORDERS.INJECT:ACCIDENTAL INJECT CAN CAUSE BURN,RED,SWELL @INJECT
PT.ACUTE/CHRONIC:PAIN,IRRIT IN CONTAM AREAS.
Explanation of Carcinogenicity:PER MSDS:NO COMPONENT OF THIS PRODUCT IS
LISTED BY NTP/IARC/FED OSHA AS CARCINOGEN.
Effects of Overexposure:SLIGHTLY IRRIT TO CONTAM TISSUE.
Medical Cond Aggravated by Exposure:EXISTING SKIN OR RESPIRATORY
CONDITIONS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT. TARGET
ORGANS:SKIN,EYE,RESPIRATORY SYSTEM.
* First Aid Measures *
First Aid:SKIN:IMMED DECONTAM W/RUN H2O.REMOVE EXPO/CONTAM CLOTH.DVLP
ADVERSE EXPO SYMPT SEEK IMMED MED ATTN.EYE:OPN EYE UNDER RUN
FRESH AIR.IF N ECESSARY USE ART RESP TO SUPPORT VITAL
FUNCTIONS.REMOVE/COVER GROSS CONTAM-AVOID RESCUERS EXPO.INGEST:CALL
DR/POIS CNTRL CNTR.NO PROF ADVICE DONT INDUCE VOMIT.TAKE
VICTIM/RESCUERS FOR MED ATTN.(SUPPL)
* Fire Fighting Measures *
Flash Point Method:OC
Lower Limits:2.6
Extinguishing Media:WATER SPRAY,DRY CHEMICAL,CARBON
DIOXIDE,HALON,FOAM,ANY ABC CLASS.
Fire Fighting Procedures:INCIPIENT FIRE RESPONDERS SHOULD WEAR EYE
PROTECTION. STRUCTURAL FIRE FIGHTERS MUST WEAR SELF-CONTAINED
BREATHING APPARATUS & FULL PROTECTIVE EQPMT.
Unusual Fire/Explosion Hazard:MATL PRESENTS SLIGHT FIRE HAZ WHEN EXPO
TO HEAT/FLAME.WHEN INVOLVE IN FIRE MATL MAY DECOMPO & PRODUCE IRRIT
FUMES & TOXIC GASES(I.E. CO, CO2).
* Accidental Release Measures *
Spill Release Procedures:UNCNTRLD RELEASES SHOULD BE RESPONDED TO BY
TRAINED PERSONNEL W/PRE-PLAN PROCEDURES.CLEAR AFFECTED AREA,PROTECT
PEOPLE,& RESOND W/PERSONNEL TRAIN IN HAZ OF PROD.MIN PPE:RUBB
MATL(OTHPREC)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE CNTNR IN COOL DRY PLACE,AWAY FRM
INCOMPA MATL.MAINTENANCE:FOLLOW PRAC IN MSDS.EPQMT LOCK/TAG OUT
SAF.USE IN ADEQU VENTI.DECONTA W/SOAPH2O BEF WK
Other Precautions:SPILL:MIN SPLASH/MIST GENERATION.DECONTAM AREA WELL
W/SOAP SOLN FOLLOW BY H2O RINSE.PLACE ALL RESIDUE IN DOUBLE PLASTIC
BAG/SEAL.DISPO OF IAW FED/STATE/LOC HAZ WASTE DISPO REGS.
* Physical/Chemical Properties *
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:N/AVAI
Decomp Temp:Decomp Text:NP
Vapor Density:APPROX 2.6
Spec Gravity:APPROX 1
pH:N/APPL
Viscosity:NP
Evaporation Rate & Reference:APROX 1, WATER=1
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS SOLUTION W/MILD ODOR.NO UNUSUAL WARNING
PROPERTIES ASSOC W/PRODUCT.
Percent Volatiles by Volume:NP
Corrosion Rate:NP
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
THIS PRODUCT IS NOT COMPATIBLE W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID CONTACT WITH INCOMPATIBLE CHEMICALS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:WASTE DISPO MUST BE IAW APPROPRIATE
FED/STATE/LOC REGS.THIS CHEM IF UNALTERED BY USE MAY BE DISPO OF BY
TREATMENT @PERMITTED FACILITY OR AS ADVISED BY YOUR LOC WASTE REG
AUTHORITY.EPA WASTE#:NA TO WAS TE CONSIST ONLY OF THIS PROD.NO SARA
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VAPOR CONCENTRATION EXCEEDS TLV, USE
RESPIRATOR APPROVED BY U.S. BUREAU OF MINES FOR ORGANIC VAPORS.
Ventilation:USE ADEQUATE VENTILATION TO KEEP VAPOR CONCENTRATION BELOW
TLV.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:WASH WITH SOAP AND WATER BEFORE HANDLING FOOD.
REMOVE CONTAMINATED CLOTHING.
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:MOLY-X SPRAY
Preparer's Name:REGULATORY AFFAIRS
* Composition/Information on Ingredients *
Ingred Name:ISOBUTANE
Other REC Limits: RECOMMENDED
Ingred Name:PROPANE
Other REC Limits: RECOMMENDED
Other REC Limits: RECOMMENDED
Fraction by Wt: 1%
Other REC Limits: RECOMMENDED
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES- IRRITATION. SKIN- MAY CAUSE
IRRITATION DUE TO DEFATTING OF SKIN. INHALATION- VAPORS CAN BE
HARMFUL. INGESTION- MAY CAUSE CHEMICAL PNEUMONITIS IF ASPIRATED
INTO LUNGS. CHRONIC: MAY CAUSE CARD IAC ABNORMALITY, KIDNEY AND/OR
LUNG DAMAGE, LIVER ABNORMALITIES, NEURAL DYSFUNCTION, ELEVATED
CARBOXYHEMOGLOBIN.
Explanation of Carcinogenicity:CONTAINS METHYLENE CHLORIDE
(DICHLOROMETHANE): POSSIBLY CARCINOGENIC TO HUMANS.
Effects of Overexposure:INHALATION- MAY CAUSE HEADACHE, DIZZINESS,
ASPHYXIA, ANESTHETIC EFFECTS AND POSSIBLE UNCONSCIOUSNESS.
INGESTION- NAUSEA, VOMITING, AND DIARRHEA.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE EXISTING EYES, SKIN,
OR UPPER RESPIRATORY CONDITIONS.
* First Aid Measures *
WATER. INHALATION- REMOVE TO FRESH AIR AND USE ARTIFICIAL
RESPIRATION IF NECESSARY. INGESTION- DO NOT INDUCE VOMITING. SEEK
MEDICAL ATTEN TION IMMEDIATELY.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DO NOT EXPOSE AEROSOLS TO TEMPERATURES
* Accidental Release Measures *
Spill Release Procedures:AVSORB WITH SUITABLE MEDIUM. INCINERATE OR
LANDFFILL ACCORDING TO LOCAL, STATE, OR FEDERAL REGULATIONS. DO NOT
FLUSH TO SEWER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT PUNCTURE OR INCINERATE
Other Precautions:AVOID FOOD CONTAMINATION. KEEP OUT OF REACH OF
CHILDREN. AVOID INHALATION OF VAPORS.
* Physical/Chemical Properties *
HCC:V2
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK SPRAY, CHLORINATED SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS.
Stability Condition to Avoid:OPEN FLME, WELDING ARCS, HEAT, SPARKS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
HYDROGEN CHLORIDE. SMALL AMOUNTS OF PHOSGENE AND CHLORINE.
* Disposal Considerations *
Waste Disposal Methods:AEROSOL CANS, WHEN VENTED TO ATMOSPHERIC
PRESSURE THROUGH NORMAL USE, POSE NO DISPOSAL HAZARD.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED TYPE RESPIRATOR FOR
PROTECTION AGAINST DUST.
Ventilation:LOCAL EXHAUST OR OTHER VENTILATION THAT WILL REDUCE DUST
CONCENTRATIONS TO LESS THAN PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:BARRIER CREAMS MAY HELP PREVENT SKIN
IRRITATION IN HYPERSENSITIVE INDIVIDUALS.
Work Hygienic Practices:PRACTICE GOOD PERSONAL HYGIENE WHEN WORKING IN
AREAS WHERE THIS MATERIAL IS USED.
Supplemental Safety and Health
EFTS OF OVEREXP: HEALTH PROFESSIONALS CONCERNING LATEST HAZARD LIST
INFO AND SAFE HANDLING & EXPOSURE INFORMATION .
* Product Identification *
CAGE:0GMG6
* Composition/Information on Ingredients *
Ingred Name:ZINC OXIDE
Ingred Name:LEAD (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CADMIUM (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ZINC OXIDE: INHAL OF HIGH LEVELS OF
ZINC OXIDE MAY RESULT IN TIGHTNESS OF CHEST, METALLIC TASTE, COUGH,
DIZZINESS, FEVER, CHILLS, HEADACHE, NAUSEA, AND DRY THROAT.
OVEREXPOSURE MAY PRODUCE SYMPTOMS KN OWN AS METAL FUME FEVER OR
"ZINC SHAKES", AN ACUTE, SELF- LIMITING CONDITION WITHOUT
RECOGNIZED (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: COMPLICATIONS. SYMPTOMS OF METAL FUME
FEVER INCLUDE: CHILLS, FEVER, MUSCULAR PAIN, NAUSEA AND VOMITING.
LIKE ANY FINELY DIVIDED PARTICULATE MATTER, ZINC OXIDE MAY CAUSE
MECHANICAL IRRITATION TO SKIN AND EYES. LEAD APPEARS ON THE NAVY
LIST OF OCCUP CHEM REPROD HAZS. SEEK CONSULTATION FROM APPROP (SUPP
DATA)
Medical Cond Aggravated by Exposure:INHALATION OF DUST MAY BE AN
IRRITANT TO PRE-EXISTING RESPIRATORY CONDITIONS.
* First Aid Measures *
First Aid:INHAL: SYMPTOMS RESULTING FROM INHAL OVEREXP USUALLY
AND POSSIBLY ASPIRIN IS RECOMMENDED TO PROVIDE RELIEF FROM FEVER
AND CHILLS. SKIN: FLUSH AREAS W/LARGE AMTS OF WATER. EYE: FLUSH
EYES W/COPIOUS AMTS OF WATER. IN ALL CASES, CONSULT MD FOR MED
ATTN. INGEST: GET MD IMMEDIATELY .
* Fire Fighting Measures *
Extinguishing Media:ZINC OXIDE DOES NOT BURN. WATER SPRAY, DRY CHEM/
CARBON DIOXIDE EXTINGUISHERS MAY BE USED FOR FIRES IN STORAGE
AREAS.
Fire Fighting Procedures:NON-FLAMMABLE. WEAR NIOSH/MSHA APPROVED SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:AS WITH ANY NUISANCE DUST, AVOID EXCESSIVE
DUSTING. MATERIAL SHOULD BE CONTAINED FOR RECYCLING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN DRY WELL-VENTILATED LOCATION.
PROTECT FROM PHYSICAL DAMAGE.
Other Precautions:AVOID PROLONGED CONTACT WITH SKIN. LEAD AND CADMIUM
ARE INHERENT IN THE MANUFACTURE OF ZINC AND ARE NOT PHYSICALLY
ADDED IN THE MANUFACTURER OF ZINC OXIDE.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE POWDER WITH NO ODOR (P AND G SUFFIX MEANS
PELLETS OR GRANULAR)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN A CLOSED CONTAINER OR HEAVY BAG.
MATERIAL MAY BE RECYCLED OR DISPOSED OF IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL ENVIRONMENTAL REGS. THIS MATERIAL MAY BE REGULATED
UNDER CERCLA, TSCA, S ARA, AND/OR RCRA REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW LEVEL OF CONCERN .
Other Protective Equipment:N/K
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.ALWAYS WASH
BEFORE EATING,SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYACRYLIC ACID (PARTIAL SODIUM SALT IN WATER)
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:LIQUID MAY CAUSE IRRITATION.SKIN:MAY BE
MILDLY IRRITATING TO SKIN WITH REPEATED OR PROLONGED
EXPOSURE.INGESTION/INHALATION:N/K .
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
MIN,HOLDING LIDS OPEN.IF IRRIT DEVELOPS,SEE MD.SKIN:REMOVE CONTAM
CLTHG.WASH WITH PLENTY OF SOAP AND WATER.IF IRRIT DEVELOPS,SEE
MD.INGESTION:CALL MD IMMEDIATELY .INHALATION:REMOVE TO FRESH
AIR.SUPPORT BREATHING (GIVE O*2/ARTIFICIAL RESPIRATION) .
* Fire Fighting Measures *
Extinguishing Media:IF WATER EVAP,DRY POLYMER MAY BURN.H*2O SPRAY,ABC
DRY CHEM & PROTEIN TYPE AIR FOAMS ARE EFFECTIVE.CO*2 POSS
INEFFECTIVE.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
.UNPROT PERS MUST LEAVE AREA.ALSO WEAR SCBA DURING CLEANUP IMMED
AFTER FIRE IN ENCLOSED/POORLY VENT AREAS.
Unusual Fire/Explosion Hazard:NONE KNOWN.HAZARDOUS DECOMPOSITION
PRODUCTS:CO,CO*2,SMALL AMOUNTS OF AROMATIC AND ALIPHATIC
HYDROCARBONS.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILL.MOP UP OR SQUEEGEE INTO CONTR OR
ABSORB W/ INERT MATL.PLACE IN CONTR,CLOSE & STORE IN SAFE AREA FOR
DISP.WASH AREA WITH SALT WATER OR DETERGENT SOLN.DO NOT FLUSH INTO
PUBLIC SEWER OR WAT ER SYS.LIQ & DRY FILM ARE SLIPPERY-AVOID FALLS.
Neutralizing Agent:WEAK CAUSTIC SUCH AS LIME OR SODA ASH.
*Handling and Storage *
Handling and Storage Precautions:AVOID SKIN/EYE CONT.KEEP CONTR
PH UNDER CAREFULLY CONTROLLED CONDITIONS.
Other Precautions:EXAMINE EACH ASPECT OF OPERATION TO DETERMINE IF
ADDITIONAL PRECAUTIONS ARE NECESSARY.DEVELOP APPROPRIATE WORK
PRACTICE GUIDELINES AND EMPLOYEE INSTRUCTIONAL PROGRAMS FOR
OPERATION.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:SEE SUPP
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:SEE SUPP
Vapor Density:SEE SUPP
Spec Gravity:SEE SUPP DATA
pH:2-5.5
Evaporation Rate & Reference:N/K
Solubility in Water:WATER DILUTABLE
Appearance and Odor:WHITE TO PINK OR AMBER,CLEAR TO SLIGHTLY HAZY
LIQUID WITH SLIGHT ACRYLIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
USE CAUTION MIXING ACIDS & BASES.INTENSE HEAT POSSIBLE IF CONTACT W/
STRONG BASES (NH*3,NAOH,KOH,STRONGLY BASIC AMINES).
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:CO,CO*2 AND SMALL AMOUNTS OF AROMATIC
AND ALIPHATIC HYDROCARBONS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISP MUST BE IAW FEDERAL,STATE & LOCAL REGS
.LIQ/DRY MATL MAY BE INCIN.NEUTRALIZE WASTE LIQ W/ LIME OR SODA ASH
(MAY BE REGULATED BY RCRA UNLESS FOR A SPILL).IF
PERMITTED,DISCHARGE NEUTRALIZED L IQ TO WASTEWATER TREATMENT
FACILITY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A RESPIRATOR THAT IS RECOMMENDED OR APPROVED
FOR USE.
Ventilation:EXHAUST VENTILATION SUFFICIENT .
RUBBER, POLYETHYLENE)
SHIELDS.
Other Protective Equipment:THE USE OF LONG SLEEVE AND LONG LEG CLOTHING
IS RECOMMENDED.
Work Hygienic Practices:NONE
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:TYPE I, ALIPHATIC ISOCYANATE
Preparer's Name:ERNEST CARTER
* Composition/Information on Ingredients *
Ingred Name:POLYMERIC HEXAMETHYLENE DIISOCYANATE
Code:F
Code:F
< Wt:5.
Ingred Name:N-BUTYL ACETATE
< Wt:5.
Ingred Name:ETHYL 3-ETHOXYPROPIONATE
* Hazards Identification *
Health Hazards Acute and Chronic:VAPORS ARE IRRITATING TO EYES, NOSE,
AND THROAT. INHALATION MAY CAUSE HEADACHES, DIFFICULT BREATHING AND
LOSS OF CONSCIOUSNESS. AS A RESULT OF PREVIOUS REPEATED
OVEREXPOSURE OR A SINGLE LARGE DOSE. CE RTAIN INDIVIDUALS WILL
DEVELOP ISOCYANATESENSITIZATION WHICH WILL CAUSE THEM TO REACT
TO A LATER EXPOSURE.
Explanation of Carcinogenicity:
Effects of Overexposure:INHALATION: FOLLOWING PROGRESSIVE STEPS:
HEADACHE, DIZZINESS, STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS OR
COMA. SKIN: SYMPTOMS MAY BE SWELLING, REDNESS, AND RASH. EYES:
LIQUID, AREOSOLS, OR VAPORS ARE IRRITATING AND MAY CAUSE TEARING,
REDNESS, AND SWELLING ACCOMPANIED BY A STINGING SENSATION.
INGESTION: CAN RESULT IN IRRITATION AND POSSIBLE CORROSIVE ACTION
IN THE MOUTH, STOMACH TISSUE AND DIG ESTIVE TRACT.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMITITIS. ISOCYANATE
SENSITIZATION.
* First Aid Measures *
First Aid:INHALATION: MOVE TO AN AREA FREE FROM RISK OF
FURTHEREXPOSURE. RESTORE BREATHING. SKIN: WASH AFFECTED AREAS
THOROUGHLY WITH SOAP AND WATER. EYES: FLUSH WITH CLEAN LUKEWARM
EYELIDS. OBTAIN MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. DO NOT GIVE ANYTHING TO AN UNCONSCIOUS PERSON. OBTAIN
MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:TCC
Autoignition Temp:Autoignition Temp Text:
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG,
WATER SPRAY.
Fire Fighting Procedures:FULL FIRE FIGHTING EQUIPMENT WITH SELF
CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING SHOULD
BE WORN BY FIRE FIGHTERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, SPARKS, ELECTRICAL EQUIPMENT AND OPEN FLAME.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION(FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN BUILDINGS DESIGNED TO COMPLY
FLAMES AND SPARK SOURCES. STORE IN TIGHTLY CLOSED CONTAINERS. STORE
IN WELL VENTILATED AREAS.
Other Precautions:KEEP CONTAINERS TIGHT AND UPRIGHT TO PREVENT LEAKAGE.
PREVENT PROLONGED BREATHING OF VAPORS OR SPRAY MISTS. PROLONGED
OVEREXPOSURE MAY CAUSE AN ALLERGIC REACTION .
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:
Decomp Temp:Decomp Text:
Vapor Density:HEAVIER
Viscosity:THIN LIQUID TO HEAVY
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID WITH SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:CONTACT WITH MOISTURE, MATERIAL WHICH
REACT WITH ISOCYANATES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE, AND CARBON DIOXIDE,
AND OXIDES OF NITROGEN, TRACES OF HCN AND HDI.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:WASTE MUST BE DISPOSED OF IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS.
| 1 | gloves_mandatory |
Subsets and Splits