text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:INDUSTRIAL ENAMEL, 139-247 BLUE BASE
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENTS
Fraction by Wt: 3.2%
Ingred Name:VEHICLE
Fraction by Wt: 44.5%
Ingred Name:AROMATIC HYDROCARBONS
Fraction by Wt: 52.3%
Other REC Limits:100 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DRYING OF SKIN, EYE IRRITAITON.
EXCESSIVE INHALAITON MAY CAUSE ANESTHESIA, HEADACHE, DIZZINESS,
NAUSEA, UPPER RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR, APPLY ARTIFICIAL RESPIRATION IF
NECESSARY, CALL PHYS. SKIN: WASH WITH MILD SOAP AND WATER, APPLY A
MILD SKIN CREAM, IN SEVERE CASES CALL PHYS. EYE: FLUSH WITH WATER
FOR AT LEAST 15 MIN, CALL PHYS. INGEST: CALL PHYS.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:80.0F,26.7C
Lower Limits:1.0%
Upper Limits:7.0%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS MAY FORM EXPLOSIVE MIXTURE WITH
AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:WASH WITH WATER INTO RETAINING AREA OR
CONTAINER. AVOID SPARKS, FIRE, OR HOT METAL SURFACES. SMALL
QUANTITIES MAY BE ABSORBED ONTO AN APPROPRIATE ABSORBANT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP COOL AND AWAY FROM SOURCES OF
IGNITIN. USE WITH ADEQUATE VENTILATION. AVOID PROLONGED OR REPEATED
PERSONAL CONTACT.
Other Precautions:AVOID HEAT, SPARKS OR OPEN FLAMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ABOVE TLV, USE NIOSH/MSHA APPROVED CARTRIDGE
RESPIRATOR OR GAS MASK.
Ventilation:LOCAL EXHAUST: USE WHATEVER IS SUFFICIENT TO KEEP WORKROOM
CONCENTRATION BELOW TLV.
Other Protective Equipment:APRON, BARRIER CREAM.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:235F,113C
Vapor Pres:23@68F
Vapor Density:3.2
Spec Gravity:0.996
Evaporation Rate & Reference:1.9(N-BUTYL ACETATE=1)
Solubility in Water:NONE
Appearance and Odor:LIGHT BLUE OPAQUE LIQUID; PUNGENT AROMATIC ODOR.
Percent Volatiles by Volume:60.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE AND DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS OR DISPOSE OF
ACCORDING TO APPLICABLE LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: 3127 HILCOTROL
Cage: FO866
=======================================================
Contractor Summary
=======================================================
Cage: 66086
Cage: FO866
=======================================================
Ingredients
=======================================================
Cas: 64742-95-6
RTECS #: WF3400000
DISTILLATES)
% Wt: >40
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
STREAMS/OTHER BODIES OF WATER. IF RUN-OFF OCCURS,
-----------------------------
-----------------------------
-----------------------------
IMPLEMENTED TO REDUCE EXPOSURE.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES:CAN CAUSE SEV IRRIT, REDNESS, TEARING, BLURRED
VISION. SKIN:PRLNG/RPTD CONT CAN CAUSE MOD IRRIT, DEFAT, DERM.
INHAL:EXCESSIVE INHAL OF VAPS CAN CAUSE NASAL & RESP IRRIT, DIZZ, WEAK,
FATG, NAUS, H DCH, POSS UNCON & EVEN ASPHY. INGEST:CAN CAUSE GI IRRIT,
NAUS, VOMIT & DIARR. ASPIR OF MATL INTO LUNGS (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:CAN CAUSE CHEMICAL PNEUMONITIS
WHICH CAN BE FATAL.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES:FLUSH W/LG AMTS OF WATER FOR AT LST 15 MINS, LIFTING UPPER
& LOWER LIDS OCCAS, GET MED ATTN. SKIN:THORO WASH EXPOS AREA W/SOAP &
WATER. REMOVE & LAUNDER CONTAM CLTHG BEFORE RE-USE. INGEST:DO NOT INDUCE
VOMIT. KEEP PERS WARM, QUIET & GET MED ATTN. ASPIR OF MATL INTO LUNGS DUE
TO VOMIT CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL. INHAL:REMOVE INDIVIDUAL TO
FRESH AIR. IF BRTHG IS DFCLT, (SUPP DATA)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SM SPILL:ABSORB LIQ ON PAPER, VERMICULITE, FLOOR
ABSORB/OTHER ABSORB MATL & TRANSFER TO HOOD. LG SPILL:ELIM ALL IGNIT
SOURCES (FLAMES, FLAMES INCL PILOT LIGHTS, ELEC SPKS). PERS NOT WEARING PROT
EQUIP SHOULD BE EXCLUDED FROM AREA OF SPILL (SUPP DATA)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: SM SPILL:ALLOW VOLAT PORTION TO EVAP IN HOOD. ALLOW
SUFFICIENT TIME FOR VAPS TO COMPLETELY CLEAR HOOD DUCT WORK. DISP OF
REMAINING MATL I/A/W STATE, FED & LOC REGS. LG SPILL:DESTROY BY LIQ
INCIN. CONT AM ABSORB MAY BE DEPOSITED IN LANDFILL
Handling And Storage Precautions: NEVER STORE IN UNLABELED OR IMPROPERLY
LABELED CONTAINER. KEEP OUT OF REACH OF CHILDREN. FOR COMMERCIAL/INDUSTRIAL
USE ONLY.
Other Precautions: CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN EMPTIED.
SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES (VAPOR, LIQUID &/OR
SOLID), ALL HAZARD PRECAUTIONS GIVEN IN THIS MSDS MUST BE OBSERVED.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 140F,60C
Lower Limits: 1%
Extinguishing Media: DRY CHEMICAL, FOAM, CO*2.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: FORMS CARBON DIOXIDE & CARBON MONOXIDE.
COMBUSTIBLE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF TLV OF PROD/ANY COMPONENT IS EXCEEDED, NIOSH/MSHA
APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE OF PROPER ENVIRON CONTROL.
OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA APPRVD RESPS UNDER SPECIFIED CNDTN S.
(SEE YOUR SAFETY EQUIP
Ventilation: PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment: TO PREVENT RPTD/PRLNG SKIN CONTACT, WEAR IMPERVIOUS
CLOTHING & BOOTS. EMERGENCY EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: FIRST AID PROC:ADMIN OXYGEN. IF BRTHG HAS
STOPPED GIVE ARTF RESP. KEEP PERS WARM, QUIET & GET MED ATTN. SPILL
PROC:UNTIL CLEAN-UP HAS BEEN COMPLETED. STOP SPILL AT SOURCE. DIKE AREA OF
SPILL TO PVNT S PREADING, PUMP LIQ TO SALVAGE TANK. REMAINING LIQ MAY BE
TAKEN UP ON SAND, CLAY, EARTH, FLOOR ABSORB/OTHER ABSORB
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 300F,149C
Vapor Pres: 3
Vapor Density: 4.5
Spec Gravity: 0.87 (H*2O=1)
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: FORMS AN EMULSION
Appearance and Odor: LIGHT AMBER LIQUID W/PLEASANT CITRUS ODOR.
Percent Volatiles by Volume: >90
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: MAY FORM TOXIC MATERIALS: CARBON DIOXIDE &
CARBON MONOXIDE, VARIOUS HYDROCARBONS, ETC.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 3127 HILCOTROL
Cage: FO866
Assigned IND: Y
Company Name: HILL MFG CO INC
Street: 1500 JONESBORO ROAD
Zipcode: 30315
Label Required IND: Y
Date Of Label Review: 02/01/1994
Status Code: C
Label Date: 02/01/1994
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: FOR COMMERCIAL OR INDUSTRIAL USE ONLY. ACUTE:EYES:CAN
CAUSE SEVERE IRRITATION, REDNESS, TEARING, BLURRED VISION. SKIN:PROLONGED OR
REPEATED CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS .
INHAL:EXCESSIVE INHALATION OF VAPORS CAN CAUSE NASAL & RESPIRATORY
IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE, POSSIBLE
UNCONSCIOUSNESS & EVEN ASPHYXIATION. INGEST:CAN CAUSE GASTROIN TESTINAL
IRRITATION, NAUSEA, VOMITING & DIARRHEA. ASPIRATION OF MATERIAL INTO
LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. CHRONIC:NONE LISTED
BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1401, 1406, KRYLON BRIGHT SILVER
CAGE:09800
CAGE:06608
CAGE:26290
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA 313) (CERCLA)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 46-47%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:750PPM/1000STEL;9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 18.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9495
Ingred Name:N-HEPTANE
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: 14-17%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:400 PPM/500STEL;9495
Ingred Name:XYLENES (O-,M-,P- ISOMERS) (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 4-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 4-4.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM; 9495
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 2.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9495
Ingred Name:HEAVY AROMATIC NAPHTHA (SOLVENT NAPHTHA)
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: 0-2.5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:PRODUCT'S LD50 (ORAL RAT) WAS NOT STATED
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:CAUSES IRRITATION. SKIN:CAUSES
IRRITATION. ABSORPTION, NO HAZARD. INGESTION:NOT EXPECTED TO BE
HARMFUL. MAY CAUSE GI TRACT IRRITATION OR BURNS. INHALATION:MAY BE
HARMFUL IF INHALED AS LIQUID OR V APOR. CAUSES CNS DEPRESSION. MAY
CAUSE LIVER/KIDNEY DAMAGE. DELIBERATELY CONCENTRATING & INHALING
VAPORS MAY BE HARMFUL.
Explanation of Carcinogenicity:AS OF THE DATE OF THE MSDS, THE MATERIAL
HAS NOT BEEN LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of Overexposure:CNS DEPRESSION, HEADACHE, DIZZINESS, NAUSEA,
VOMITING, UNCONSCIOUSNESS, ASPHYXIATION.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION ON MSDS.
======================= First Aid Measures =======================
First Aid:IF IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL ATTENTION.
EYE:FLUSH W/WATER TO 15 MIN. SKIN:WASH W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. INHALED:REMOVE FROM
EXPOSURE. AI D OR RESTORE BREATHING AS NEEDED. INGESTED:DILUTE BY
DRINKING LARGE QUANTITIES OF WATER & CONTACT POISON CONTROL CENTER
OR HOSPITAL EMERGENCY ROOM FOR ADDITIONAL TREATMENT.
===================== Fire Fighting Measures =====================
Flash Point:EXTREMELY FLAMBL
Extinguishing Media:DRY CHEMICAL,CARBON DIOXIDE,FOAM. WATER MAY BE
INEFFECTIVE, USE IT TO COOL FIRE EXP0SED CONTAINERS.
Fire Fighting Procedures:HIGH TEMPERATURES MAY CAUSE BURSTING. DO NOT
PLACE CONTAINER ON RADIATOR, STOVE, DIRECT SUNLIGHT OR OTHER HEAT
SOURCE. DO NOT PUNCTURE. CONTENTS UNDER PRESSURE.
Unusual Fire/Explosion Hazard:VAPOR MAY IGNITE EXPLOSIVELY. SPRAY MIST
OR VAPOR IS HEAVIER THAN AIR & MAY TRAVEL ALONG GROUND/LOW PLACES
TO IGNITION SOURCE & FLASHBACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. SOAK UP W/
ABSORBENT MATERIAL & REMOVE TO A CHEMICAL DISPOSAL AREA. PREVENT
ENTRY INTO NATURAL BODIES OF WATER.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT TEMPERATURES ABOVE
120F.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE AIR CONTAMINANTS CAN EXCEED ACCEPTABLE
CRITERIA USE NIOSH/MSHA APPROVED RESPIRATORY PROTECTION EQUIPMENT.
SELECT RESPIRATORS BASED ON FORM & CONCENTRATION OF CONTAMINANTS IN
AIR I/A/W OSHA 29CFR 1910.134 OR OTHER APPLICABLE STANDARD.
Ventilation:USE SUFFICIENT VENTILATION IN VOLUME & AIR FLOW PATTERN TO
KEEP CONTAMINANT CONCENTRATION BELOW ACCEPTABLE CRITERIA.
Other Protective Equipment:MFR GAVE NO INFORMATION ON MSDS.
Work Hygienic Practices:MFR:?. HMIS:USE GOOD CHEMICAL HYGIENE
PRACTICES. AVOID CONTACT IF AT ALL POSSIBLE. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V3
NRC/State Lic Num:NONE
Vapor Pres:SEE CAN
Vapor Density:>1
Spec Gravity:<1
Viscosity:NOT KNOWN
Solubility in Water:SLIGHT
Appearance and Odor:MFR GAVE NO INFORMATION ON MSDS. PRESSURE IN
CONTAINER = 50 PSI.
Percent Volatiles by Volume:87-90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MFR GAVE NO INFORMATION ON MSDS.
Stability Condition to Avoid:MFR GAVE NO INFORMATION ON MSDS.
Hazardous Decomposition Products:OXIDES OF CARBON.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE, PROVINCIAL &
LOCAL REQUIREMENTS. EMPTY CONTAINER MAY CONTAIN EXPLOSIVE VAPORS.
DO NOT CUT, PUNCTURE, OR WELD NEARBY. INCINERATION WILL CAUSE
CONTAINER TO BURST VIOLENT LY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:POTASSIUM CHLORIDE SOLUTIONS;SO-P-138
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM CHLORIDE (26.0-28.5%)
CAS:7447-40-7
RTECS #:TS8050000
Fraction by Wt: 26.0-28%
Ingred Name:SILVER CHLORIDE (AS NUISANCE DUST)
CAS:7783-90-6
RTECS #:VW3563000
Fraction by Wt: 0.0-0.1%
OSHA PEL:15 MG/M3 TOTAL DUST
ACGIH TLV:10 MG/M3 TDUST;8990
Ingred Name:HYDROGEN CHLORIDE (HYDROCHLORIC ACID) (SARA III)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 0.0-.02%
OSHA PEL:C 5 PPM
ACGIH TLV:C 5 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 71.5-74%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL MOUSE 2500 MG/KG
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:NO DATA AVAILABLE IN CASE OF
INHALATION OR SKIN CONTACT;MAY CAUSE EYES AND IN CASE INGESTION MAY
CAUSE G.I. TRACT IRRITATION,NAUSEA,VOMITING,ABDOMINAL PAIN AND
DIARRHEA. CHRONIC:SKIN RASHES POSS IBLE (AGCL & HCL IS NEGLIGIBLE
AMOUNT AS IMPURITIES;NO HEALTH EFFECTS ARE EXPECTED).
Explanation of Carcinogenicity:PER MSDS.
Effects of Overexposure:SEE HEALT HAZARDS DATA.
Medical Cond Aggravated by Exposure:NONE NOTED.
======================= First Aid Measures =======================
First Aid:INHALATION:NO PROBLEM IS ANTICIPATED;REMOVE TO FRESH AIR IF
NEEDED. EYES:WASH THOROUGHLY WITH PLENTY OF WATER FOR ABOUT 15
MINUTES;CONSULT A PHYSICIAN. SKIN:WASH WITH PLENTY OF WATER.
INGESTION:GIVE L ARGE AMOUNT OF WATER;DO NOT INDUCE VOMITING;GET
MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL,CO*2,HALON,WATER SPRAY.FOAM FOR NORMAL
FIRE IF APPLICABLE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA IN AN ENCLOSED
AREA.
Unusual Fire/Explosion Hazard:NONE NOTED;AVOID BREATHING HAZARDOUS
VAPORS,KEEP UPWIND.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;SOAK UP SPILL
WITH VERMICULITE AND PLACE IN A SUITABLE CONTAINER FOR PROPER
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AREA;DO NOT TAKE
INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED;PROVIDE AN ADEQUATE
VENTILATION.
Ventilation:GENERAL DILUTE VENTILATION.
Other Protective Equipment:APRON;EYE-WASH FACILITIES.
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST;DO NOT TAKE INTERNALLY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F/100C
Melt/Freeze Pt:M.P/F.P Text:14F/-10C
Vapor Pres:14 MMHG
Vapor Density:0.7 (WATER
Spec Gravity:1.2
Evaporation Rate & Reference:>1 (ETHER=1)
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS LIQUID CONTAINING CRYSTALS OF POTASSIUM
CHLORIDE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
TRIFLUOROBROMIDE,SULFURIC ACID,POTASSIUM PERMANGANATE.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:POSSIBLE HCL.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH LOCAL,STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FA3135
CAGE:JO774
CAGE:81831
CAGE:JO774
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS PE RSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Other Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMATIC ODOR.
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WS COMPOUND, SLURRY, THINNER
CAGE:5N010
CAGE:5N010
============= Composition/Information on Ingredients =============
Ingred Name:POLYETHYLENE GLYCOL. (PEG)
CAS:25322-68-3
RTECS #:TQ3500000
OSHA PEL:NAIF
ACGIH TLV:NAIF
Ingred Name:COLLOIDAL SILICA
CAS:7631-86-9
OSHA PEL:NAIF
ACGIH TLV:NAIF
Ingred Name:DIAMOND.
CAS:7782-40-3
OSHA PEL:NAIF
ACGIH TLV:NAIF
Ingred Name:POLYALKYLENE GLYCOL. (PAG)
CAS:9038-95-3
RTECS #:MO0911000
OSHA PEL:NAIF
ACGIH TLV:NAIF
Ingred Name:FATTY ACID ESTER
CAS:61791-00-2
OSHA PEL:NAIF
ACGIH TLV:NAIF
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NO EVIDENCE OF ADVERSE
EFFECT. INGESTION: NO EVIDENCE OF ADVERSE EFFECT. SKIN: MAY CAUSE
MODERATE TO SEVERE REDDENING. EYE: CAUSES MODERATE TO SEVERE
IRRITATION. OTHER POTENTIAL HEALTH RI SKS: N/A.
Effects of Overexposure:REFER TO HEALTH HAZARD ACUTE AND CHRONIC.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. INGESTION: NO HARMFUL
EFFECTS EXPECTED. SKIN: WASH WITH SOAP AND WATER.EYES: FLUSH
THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES. SEEK MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:=93.3C, 200.F
Lower Limits:0.5
Upper Limits:1.8
Extinguishing Media:CO2 OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS CAN BE FLUSHED WITH LARGE AMOUNTS
OF WATER, LARGE SPILLS SHOULD BE COLLECTED.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID OPEN FLAMES, STRONG ACIDS AND
TEMPERATURES EXCEEDING 200F. USE ADEQUATE VENTILATION. WASH HANDS.
Other Precautions:MEASURES TO BE TAKEN DURING REPAIR AND MAINTENANCE OF
CONTAMINATED EQUIPMENT: WASH HANDS WITH SOAP AND WATER. AVOID
SMOKING AND/OR OPEN FLAME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH APPROVED RESPIRATOR APPROPRIATE FOR THE
EXPOSURE OF CONCERN .
Ventilation:LOCAL: AVOID CONFINED SPACES. MECHANICAL (GENERAL): GENERAL
FACTORY EXHAUST FAN. OTHER: N/A.
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. AVOID SMOKING.
Supplemental Safety and Health
PHYSICAL/CHEMICAL PROPERTIES: ALCOHOL SOL: SOLUBLE. SOLVENT SOL:
OXYGENATED SOLVENTS.
================== Physical/Chemical Properties ==================
Boiling Pt:>176.7C, 350.F
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:@20C 0.001
Vapor Density:NA
Spec Gravity:@20C 0.991
Evaporation Rate & Reference:NA
Solubility in Water:SOLUBLE. (SUPP DATA)
Appearance and Odor:TRANSLUCENT, LOW ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NORMALLY UNREACTIVE: HOWEVER AVOID STRONG BASES AT HIGH TEMPERATURES,
STRONG ACIDS, STRONG OXIDIZING AGENTS AND MATERIALS REACTIVE WITH
HYDROXYL COMPOUND.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:BURNING MAY PRODUCE CARBON DIOXIDE,
CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS . INCINERATE IN A FURNACE
WHERE PERMITTED UNDER APPROPRIATE FEDERAL, STATE, AND LOCAL
REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DIESEL FUEL NO. 2, LOW/HIGH SULFUR; 3502;3504;3510;4152.
Preparer's Name:MSDS ADMINISTRATOR
CAGE:5R396
CAGE:5R396
============= Composition/Information on Ingredients =============
Ingred Name:DIESEL FUEL, NO. 2 (PETROLEUM MID-DISTILLATE).
CAS:68476-34-6
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL RAT = 9ML/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE IRRIT TO EYES/LUNGS/SKIN AFT
PROLONG/REPEAT EXPOSURE. ASPIRATION INTO LUNGS MAY CAUSE LUNG
DAMAGE & DEATH.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:OVEREXPOSURE MAY CAUSE WEAKNESS,HEADACHE,
NAUSEA,CONFUSION,BLURRED VISION,DROWSINESS,UNSPECIFIED CNS
EFFECTS.LARGE EXPOSURE MAY CAUSE DIZZINESS,SLURRED SPEECH,FLUSHED
FACE,UNCONSCIOUSNESS, CONVULSIONS .STUDIES IN MICE/RATS W/CHRONIC
EXPOUSRE HAVE SHOWN DIESEL EXHAUST MAY PRODUCE LUNG TUMORS AND
LYMPHOMAS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MFG.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN IF BREATH DIFFI OR ARTI
RESP IF NOT BRETH.CALL PHYSICIAN.SKIN:WASH W/SOAP & WATER.IF IRRIT
DEVELOP/PERSIST,CALL PHYSICIAN.EYES:IMMED FLUSH W/PLENTY OF WATER
FOR @ 15MINS.CALL PHYSICIAN.INGEST:DO NOT INDUCE VOMITING.IF
CONSCIOUS GIVE 2 GLASSES OF WATER.PHYSICIAN:GIVE 5ML/KG (OR 350ML)
OF CHARCOAL SOLUTION (50GMS CHARCOAL IN 400ML WATER).
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:130F,54C
Lower Limits:0.4
Upper Limits:6
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
NFPA CLASSIFICATION:CLASS II COMBUSTIBLE LIQUID.
Fire Fighting Procedures:DON'T ENTER ENCLOSE/CONFINE SPACE W/O PROPER
PROT EQPMT INCLUDING RESP PROT.W/WATER SPRAY COOL FIRE EXPOSED
CNTNRS & DISPERSE/FLUSH VAP/PROTECT FROM SPILL/LEAK.
Unusual Fire/Explosion Hazard:PRODUCTS OF COMBUSTION MAY CONTAIN CARBON
MONOXIDE, CARBON DIOXIDE & OTHER TOXIC MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.USE EXPLOSION-PROOF
EQPMT & APPROPRIATE PPE.DIKE & PREVENT FROM ENTERING
SEWERS/WATERWAYS.SOAK UP W/ABSORBENT MATL.(SAWDUST,SAND,OIL DRY).IF
SPILLED INTO NAVIGABLE WATERS REPOR T TO NAT RESP CNTR
800-424-8802.READ MSDS.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN WELL-VENTILATED AREA.KEEP
CONTAINER TIGHTLY CLOSED.STORE IAW NAT FIRE PROTECTION ASSOC
RECOMMENDATIONS.STORE AWAY FROM HEAT/SPARKS/FLAME/OXID
Other Precautions:DO NOT BREATH VAPORS/MISTS.GROUND CONTAINERS WHEN
TRANSFERRING LIQUID (FLOWING FUEL GENERATES STATIC ELECTRICITY).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELECT APPROPRIATE NIOSH-APPROVED RESP
PROTECTION WHEN NEEDED TO AVOID INHAL OF MIST/VAPORS AND TO
MAINTAIN EXPOSURES BELOW ACCEPTABLE LIMITS.
Ventilation:USE ONLY WITH ADEQUATE VENTILATION. MECHANICAL (GENERAL)
VENTILATION TO MAINTAIN TLV/PEL.
Other Protective Equipment:COVERALLS IF SPLASHING IS PROBABLE.
Work Hygienic Practices:WASH HANDS AFTER HANDLING. LAUNDER CONTAMIN
CLOTHES PRIOR TO REUSE.
Supplemental Safety and Health
NOT SUBJECT TO CA PROP 65. CONTAINS DIESEL FUEL OIL SUBJECT TO PEN
WORKER/COMM RIGHT TO KNOW.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:350F,177C
Vapor Pres:1MM@68F
Vapor Density:>1
Spec Gravity:0.84-0.88 @60C
Viscosity:1.9CAT@40C
Solubility in Water:INSOLUBLE
Appearance and Odor:AROMATIC ODOR;LIQUID;HIGH SULFUR-GREEN;LOW
SULFUR-RED OR UNDYED(CLEAR OR STRAW)
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCMPATIBLE OR CAN REAC WTIH STRONG OXIDIZERS.
Stability Condition to Avoid:AVOID HEAT, SPARKS, FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, AND
OTHER TOXIC MATERIALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:TREATMENT/STORAGE/TRANSP/DISPOSAL MUST BE IAW
APPLICABLE FED/STATE/PROVINCIAL/LOC REGS.DO NOT FLUSH TO SURFACE
WATER/SANITARY SEWER SYS.BY ITSELF LIQ IS EXPECTED TO BE RCRA
IGNITABLE HAZ WASTE.CONTAIN S PETRO
HYDROCARBONS-RQ(FILM/SHEEN/DISCOLO WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CUSTOM PLASMA STANDARD, PLPT3-2X
Preparer's Name:LINDA OLCHVARY
CAGE:07977
CAGE:07977
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCHLORIC ACID; (HYDROGEN CHLORIDE)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 10%
OSHA PEL:5 PPM, C
ACGIH TLV:5 PPM, C
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PLATINATE (2-), HEXACHLORO-, DIHYDROGEN, (OC-6-11)-;
(CHLOROPLATINIC ACID)
CAS:16941-12-1
RTECS #:TP1500000
Fraction by Wt: 0.1-1%
OSHA PEL:0.002 MG/M3
ACGIH TLV:0.002 MG/M3
Ingred Name:SUPP DATA: SOLNS MAY CAUSE DERMAT. EROSION OF TEETH MAY
OCCUR W/PRLNGD EXPOS TO CONC HYDROCHLORIC ACID. INGEST (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: OF LIQ CAUSES SEVERE BURNS OF MUC MEMB OF MOUTH,
ESOPHAGUS & STOMACH, CAUSING PAIN, NAUS & VOMIT. INHAL (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: OF CONC HYDROCHLORIC ACID MAY BE FATAL CAUSING
SPASM, SEVERE IRRIT OF UPPER RESP TRACT, INFLAM & EDEMA OF(ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: LARYNX & BRONCHI & CHEM PNEUM. SYMP INCL COUGHING,
BURNING OF THROAT, INFLAM OF NOSE & CHOKING SENSATION.(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: IF INHALED DEEPLY PULMONARY EDEMA MAY OCCUR.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:AVOID INGEST, INHAL & SKIN/EYE CONT
W/CHLOROPLATINIC ACID. INHAL MAY LEAD TO PLATINOSIS. PLATINOSIS IS
CHARACT BY ASTHMA, ECZEMA & UTICARA/IT MAY BE ASYMPOMATIC & CHARACT
BY COUGH, DYSPNEA, ITCHING, C ONJ VASODILATATION, AND
RHINOPHARYNGITIS. SKIN CONT CAN RESULT IN CONT DERMAT. CONC
HYDROCHLORIC ACID(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: MAY BE FATAL IF INHALED,
INGESTED/ABSORBED THRU SKIN. HYDROCHLORIC ACID VAPOR/MIST IS AN
IRRITANT OF THE EYES, MUC MEMB, SKIN & UPPER RESP TRACT. WHEN CONC
HYDROCHLORIC ACID IS IN CONT W/EYE S, IT PRODUCES SEVERE BURNS WICH
MAY RESULT IN PRLNGD/PERMANENT VISUAL IMPAIRMENT, INCL TOTAL LOSS
OF VISION.(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MIN OCCASNLY LIFTING
UPPER & LOWER LIDS. SKIN: REMOVE CONTAM CLTHG, THEN FLUSH W/WATER
FOR AT LEAST 15 MIN. WASH CLTHG THORO BEFORE REUSE. INHAL: MOVE TO
FRESH AIR.INGEST: DO NOT INDUCE VOMITING. IMMED GET MED HELP.
SEND TO HOSPITAL. ONLY IF PATIENT IS CONSCIOUS, GIVE LARGE QTYS OF
WATER OR MILK. IF IRRIT CONTINUES, GET MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:APPROPRIATE TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. DILUTE SPILL W/WATER & NEUT W/SODA
ASH, LIMESTONE, ETC. WIPE UP & PUT IN SEALED CNTNR FOR PROPER DISP.
WASH SPILL SITE OFF W/WATER AFTER MATL PICK-UP IS COMPLETE. WEAR
RESP.
Neutralizing Agent:SODA ASH, LIMESTONE.
======================Handling and Storage ======================
Handling and Storage Precautions:HYDROCHLORIC ACID WILL ATTACK MOST
METALS & SOME FORMS OF PLASTICS, RUBBER & COATINGS. STORE AT ROOM
TEMP. KEEP TIGHTLY SEALED WHEN NOT IN USE.
Other Precautions:AVOID INHALATION, INGESTION & CONTACT WITH EYES &
SKIN. IRRITANT AND CORROSIVE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:CHEMICAL FUME HOOD.
Other Protective Equipment:LAB COAT. CHEM RESISTANT CLOTHING. HAVE
IMMEDIATE AVAILABILITY OF AN EYEWASH IN CASE OF EMERGENCY. DELUGE
SHOWER .
Work Hygienic Practices:WASH CAREFULLY AFTER USE.
Supplemental Safety and Health
MATL TO AVOID: ACID COMES IN CONT W/MOST METALS IT CORRODES THEM
SEVERELY & FORMS FLAM HYDROGEN GAS. CONT W/ANY ALKALI/ACTIVE METAL
MAY DEV ENOUGH HEAT TO CAUSE FIRE IN ADJACENT COMBUST MATL. EFTS OF
OVEREXP: ON THE SKIN, THE CONC LIQ/VAP WILL CAUSE REDNESS, PAIN &
SEVERE BURNS. RPTD/PRLNGD EXPOS TO DILUTE (ING 3)
================== Physical/Chemical Properties ==================
HCC:C1
Spec Gravity:APPROX 1
Solubility in Water:SOLUBLE
Appearance and Odor:TRANSPARENT SOLUTION WITH AN ACRID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, AMINES, ALKALI METALS, COPPER, COPPER ALLOYS, ALUMINUM & HCL
CORRODES STEEL. WHEN CONC HYDROCHLORIC (SUPP DATA)
Stability Condition to Avoid:ELEVATED TEMPERATURES.
Hazardous Decomposition Products:WILL RELEASE TOXIC FUMES OF HYDROGEN
CHLORIDE GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT LOCAL HAZARDOUS OR CHEMICAL WASTE
DISPOSAL AGENCY FOR LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CARBOWAX PEG 8000, P15510007
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:POLY(OXY-1,2-ETHANEDIYL), .ALPHA.-HYDRO-.OMEGA.-HYDROXY-
EINECS/ELINCS: UNLISTED.
CAS:25322-68-3
RTECS #:TQ3500000
Fraction by Wt: 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT)28 GM/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: MAY CAUSE MILD EYE
IRRITATION. SKIN: LOW HAZARD FOR USUAL INDUSTRIAL HANDLING.
INGESTION: MAY CAUSE GASTROINTESTINAL IRRITATION WITH NAUSEA,
VOMITING AND DIARRHEA. INHALATION: NO HAZARD EX PECTED IN NORMAL
INDUSTRIAL USE. CHRONIC: PROLONGED OR REPEATED SKIN CONTACT MAY
CAUSE DERMATITIS. TARGET ORGANS: NONE.
Explanation of Carcinogenicity:CAS# 25322-68-3: NOT LISTED BY ACGIH,
IARC, NIOSH, NTP, OR OSHA.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LST 15
MINS, OCCASIONALLY LIFTING UPPER & LOWER LIDS. GET MED AID. SKIN:
FLUSH WITH PLENTY OF SOAP AND WATER FOR AT LST 15 MINS WHILE
REMOVING CONTA MD CLOTHING & SHOES. GET MED AID IF IRRIT DEVELOPS
OR PERSISTS. INGEST: IF VICTIM IS CONSCIOUS & ALERT, GIVE 2-4
CUPFULS OF MILK OR WATER. NEVER GIVE ANYTHING BY MOUTH TO
UNCONSCIOUS PERSON. GET MED A ID. INHAL: REMOVE FROM EXPOSURE TO
FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT,
GIVE OXYGEN. GET MED AID. NOTES TO PHYS: TREAT SYMPTOMATICALLY &
SUPPORTIVELY.
===================== Fire Fighting Measures =====================
Flash Point:=268.C, 514.4F
Extinguishing Media:IN CASE OF FIRE, USE WATER, DRY CHEMICAL, CHEMICAL
FOAM, OR ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:AS IN ANY FIRE, WEAR A SELF-CONTAINED
BREATHING APPARATUS IN PRESSURE-DEMAND, NIOSH (APPROVED OR
EQUIVALENT), AND FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:DUSTS A SUFFICIENT CONCENTRATIONS CAN
FORM EXPLOSIVE MIXTURES WITH AIR. DURING A FIRE, IRRITATING AND
HIGHLY TOXIC GASES MAY BE GENERATED BY THERMAL DECOMPOSITION OF
COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:GENERAL INFORMATION: USE PROPER PERSONAL
PROTECTIVE EQUIPMENT AS INDICATED IN EXPOSURE CONTROLS, PERSONAL
PROTECTION (SECTION 8). SPILLS/LEAKS: SWEEP UP OR ABSORB MATERIAL,
THEN PLACE INTO A SUITABLECLEAN, DRY, CLOSED CONTAINER FOR
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:CAUTION! THIS IS EXPECTED TO BE A LOW
HAZARD FOR USUAL INDUSTRIAL HANDLING. MAY CAUSE IRRITATION. USE
WITH ADEQUATE VENTILATION.
Other Precautions:STORE IN A COOL, DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1910.134 OR EUROPEAN STANDARD EN 149. ALWAYS USE A NIOSH OR
EUROPEAN STANDARD EN 149 APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL
AIRBORNE LEVELS.
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN
EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
FED REGULATORY INFO: UNDER CWA. OSHA: NONE OF CHEMS IN THIS PROD ARE
CONSIDERED HIGHLY HAZ BY OSHA. SECTION 302(RQ): NONE OF CHEMS IN
MATL HAVE RQ. SECTION 302(TPQ): NONE OF CHEMS IN PROD HAVE TPQ. OS
HA: NONE OF CHEMS IN PROD ARE CONSIDERED HIGH HAZ BY OSHA.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:=60.C, 140.F
Vapor Pres:NOT AVAILABLE
Vapor Density:NOT AVAIL
Spec Gravity:1.20
pH:NOT AVAIL
Viscosity:NOT AVAIL
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE SOLID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:LD50/LC50: CAS# 25322-68-3: ORAL,MOUSE = 34
GM/KG; ORAL, RABBIT: LD50 = 14 GM/KG; ORAL, RAT: DL50 = 28 GM/KG;
SKIN, RABBIT: LD50 = >20 GM/KG. EPIDEMIOLOGY, TERATOGENICITY,
REPRODUCTIVE EFFECTS, NEUROT OXICITY, MUTAGENICITY, AND OTHER
STUDIES: NO DATA AVAILABLE.
===================== Ecological Information =====================
Ecological:ECOTOXICITY, ENVIRONMENTAL FATE, PHYSICAL/CHEMICAL AND
OTHER: NOT AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS. RCRA D-SERIES MAX CONC OF
CONTAMINANTS: NONE LISTED. RCRA D-SERIES CHRONIC TOXICITY REFERENCE
LEVELS: NONE LISTED. RCRA F, P, & U SERIES: NONE LISTED.
=================== MSDS Transport Information ===================
Transport Information:NO INFORMATION AVAILABLE.
===================== Regulatory Information =====================
SARA Title III Information:NO CHEMICAL ARE REPORTABLE UNDER SECTION
313.
Federal Regulatory Information:TSCA CAS #25322-68-3 IS LISTED ON TSCA
INVENTORY. HLTH & SFTY RPTG LIST: NONE OF CHEMS IN PROD ARE UNDER
CHEM TEST RULE. SECTON 12B: NONE OF CHEMS ARE LISTED UNDER TSCA
SECTION 12B. TSCA SIGNIFICANT N EW USE FULE: NONE OF CHEMS IN MATL
HAVESNUR UNDER TSCA. CLEAN AIR ACT: THIS MATL DOES NOT CNTN ANY HAZ
AIR POLLUTANTS. THIS MATL DOES NOT CNTN ANY CLASS 1 OZONE
DEPLETORS. THIS MATL DOES NOT CNTN ANY CLASS 2 OZONE DEPLETORS.
CLEAN WATER ACT: NONE OF CHEMS IN PROD ARE LISTED AS HAZ SUBSTANCES
UNDER C WA. NONE OF CHEMS IN PROD ARE LISTED AS TOXIC POLLUTANTS
(SUPDAT)
State Regulatory Information:CAS# 25322-68-3 CAN BE FOUND ON FOLLOWING
STATE RIGHT TO KNOW LISTS: MINNESOTA. CALIFORNIA NO SIGNIFICANT
RISK LEVEL: NONE OF CHEMS IN THIS PROD ARE LISTED.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CHERRY WAX
CAGE:002W4
CAGE:002W4
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
CAS:111-76-2
RTECS #:KJ8575000
Other REC Limits:25 PPM (SKIN)
OSHA PEL:50 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NON-TOXIC.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NON-TOXIC.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/CLEAR WATER FOR 15 MINS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Fire Fighting Procedures:NON REQUIRED
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:RINSE AREA W/CLEAR WATER & FLUSH TO DRAIN.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. KEEP LID CLOSED
WHEN NOT IN USE.
Other Precautions:KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NECESSARY.
Other Protective Equipment:NONE REQUIRED
Work Hygienic Practices:WASH HANDS AFTER EACH USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Melt/Freeze Pt:M.P/F.P Text:AS WATER
Vapor Pres:AS WATER
Vapor Density:AS WATER
Spec Gravity:1.09
Evaporation Rate & Reference:AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:THICK RED LIQUID W/CHERRY FRAGRANCE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS
Stability Condition to Avoid:FREEZING
Hazardous Decomposition Products:IF HEATED TO DECOMPOSITION, MAY EMIT
NOXIOUS OXIDE FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ALL FLEET MOTOR OIL SAE 15W40, 388 (5 GAL)
CAGE:72527
CAGE:72527
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENTS
Ingred Name:SUPP DATA: EARTH, FLOOR ABSORBENT, OR OTHER ABSORBENT
MATERIAL AND SHOVELED INTO CONTAINERS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: KEEP PERSON WARM, QUIET AND GET MEDICAL
ATTENTION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: POTENTIAL LOCAL AND SYSTEMIC
EFFECTS DUE TO SINGLE OR SHORT TERM OVEREXPOSURE TO THE EYES AND
SKIN OR THROUGH INHALATION OR INGESTION. TOXICOLOGICAL TESTING
INDICATES THAT SIMILAR PRODUCTS ARE NOT HAZARDOUS AS DEFINED BY
OSHA (29 CFR 1910.1200).
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:THORO WASH W/SOAP & WATER.REMOVE CONTAMD CLTHG. LAUNDER
CONTAMD CLTHG BEFORE RE-USE. EYES:FLUSH W/LG AMTS OF WATER FOR @
LST 15 MIN, LIFTING LIDS OCCASIONALLY, GET MED ATTN. INGEST:DO NOT
INDUCE VOMIT, KEEP PERS WARM & QUIET & GET MEDATTN. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCON PERS. INHAL:MOVE TO FRESH AIR. IF
BRTHG IS DFCLT, ADMIN OXYGEN. IF BRTHG HAS STOPPED GIVE ARTF RESP.
(ING 3)
===================== Fire Fighting Measures =====================
Flash Point:>400F,>204C
Extinguishing Media:REGULAR FOAM OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER/FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT & POSS
ENDANGER LIFE OF FIREFIGHTER, (SUPP DATA)
Unusual Fire/Explosion Hazard:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUM (EVEN EMPTY) BECAUSE PRODUCT (EVEN JUST RESIDUE) CAN
IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:SM:ABSORB LIQ ON PAPER, VERMICULITE, FLOOR
ABSORBENT/OTHER ABSORBENT MATL & TRANSFER TO HOOD.LG:PREVENT
RUN-OFF TO SEWERS, STREAMS/OTHER BODIES OF WATER.IF RUN-OFF OCCURS,
NOTIFY PROPER AUTHORITIES AS REQD, THAT SPILL HAS OCCURRED.
PERSONS(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT TRANSFER TO UNLABELED
CONTAINER. DO NOT USE CUTTING OR WELDING TORCH ON THIS CONTAINER
(EVEN EMPTY). FOR INDUSTRIAL USE ONLY.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES (VAPOR,
LIQUID, AND/SOLID), ALL HAZARD PRECAUTIONS GIVEN IN THIS MSDS MUST
BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN
.
Ventilation:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS AND LEGS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:ESPECIALLY IF SPRAYED INTO CNTNR OF HOT, BURNING LIQ.
SPILL PROC: NOT WEARING PROT EQUIP SHLD BE EXCLUDED FROM AREA OF
SPILL UNTIL CLEAN-UP HAS BEEN COMPLETED. STOP SPILL @ SOURCE, DIK E
AREA OF SPILL TO PVNT SPREADING, PUMPLIQ TO SALVAGE TANK. REMAINING
LIQ MAY BE TAKEN UP ON SAND, CLAY, (ING 2)
================== Physical/Chemical Properties ==================
HCC:V6
Vapor Density:HVR/AIR
Spec Gravity:0.881 @ 60F
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:CLEAR BRIGHT HOMOGENEOUS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:SM:ALLOW VOLAT PORTION TO EVAP IN HOOD.ALLOW
SUFFICIENT TIME FOR VAPS TO COMPLETELY CLEAR HOOD DUCT WORK.DISPOSE
OF REMAINING MATL I/A/W APPLIC REGS. LG:DESTROY BY LIQ
INCIN.CONTAMD ABSORB MAY BE DEPO SITED IN LANDFILL I/A/W LOCAL,
STATE &FED REGS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:MIL-H-5606E(1) QA, PROD. CODE- 25303
Preparer's Name:LAB MANAGER
CAGE:92895
CAGE:92895
============= Composition/Information on Ingredients =============
Ingred Name:INFORMATION WITHHELD AS A TRADE SECRET. THE PRODUCT IS A
HYDROTREATED PETROLEUM HYDROCARBON.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:MILD EYE IRRITATION POSSIBLE IN
ENCLOSED AREAS. MILD SKIN IRRITATION POSSIBLE WITH PROLONGED
CONTACT.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:EYES: MILD IRRITATION, REDNESS. SKIN: MILD
IRRITATION, POSSIBLE DERMATITIS, HEADACHE, POSSIBLE UNCONCIOUSNESS.
INGESTION: NAUSEA, VOMITING, DIARRHEA, GASTROINTESTINAL IRRITATION.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: IMMEDIATELY FLUSH WITH
PLENTY OF WATER FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND
WATER. INGESTION: DO NOT INDUCE VOMITING. GIVENOTHING BY MOUTH IF
UNCONSCIOUS. GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:200F,93C
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:DRY CHEMICAL,FOAM,CARBON DIOXIDE OR WATER FOG
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS IN
ENCLOSED AREA
Unusual Fire/Explosion Hazard:DO NOT USE DIRECT STREAM OF
WATER.MATERIAL MAY FLOAT AND REIGNITE.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE LIQUID.ADD ABSORBENT TO SPILL
AREA.VENTILATE ENCLOSED SPACES.KEEP PETROLEUM PRODUCTS OUT OF
STREAMS & WATERWAYS
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS/MIST IF > TLV.
Ventilation:EXHAUST FAN
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
================== Physical/Chemical Properties ==================
HCC:V6
Vapor Pres:0.07
Spec Gravity:0.872
Evaporation Rate & Reference:<0.01 (BUTYL ACETATE=1)
Solubility in Water:NIL
Appearance and Odor:CLEAR RED LIQUID WITH SLIGHT ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS LIKE CHLORINE AND OXYGEN, STRONG ACIDS OR
ALKALIES.
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CARBON MONOXIDE IN THE CASE OF
INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. ALL
RECOVERED MATERIAL SHOULD BE PACKAGED, LABELLED, TRANSPORTED, AND
DISPOSED OF OR RECLAIMED IN CONFORMANCE WITH GOOD ENGINEERING
PRACTICES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DIMETHYGLYOXIME (PRACT)
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:DIMETHYLGLYOXIME
CAS:95-45-4
RTECS #:EK2975000
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:NONE KNOWN. OF LOW HAZARD TO HEALTH
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CO*2,DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP ONTO PAPER. PLACE IN FIBES CARTON. BURN
IN INCINERATOR
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:LOCAL/MECHANICAL
Supplemental Safety and Health
PKG SIZE: 1 LB BOTTLE. MFR ID 98
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Density:4
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TRICLINIC CRYSTALS,NEARLY WHITE POWDER OR CRYSTALS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:EMITS TOXIC FUMES OF NITROGEN OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE IN FLAMMABLE SOLVENT,SPRAY INTO
INCINERATOR EQUIPPED WITH AFTERBURNER AND SCRUBBER. STATE,LOCAL AND
FEDERAL LAWS TAKEK PRECEDENCE
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ST-16
Preparer's Name:ARTHUR A. SAUPE
CAGE:4Y322
CAGE:4Y322
============= Composition/Information on Ingredients =============
Ingred Name:POLYDIMETHYLSILOXANE
CAS:63148-62-9
RTECS #:JT6484500
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:LOW TOXICITY, POSS EYE IRRT.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH 15 MIN W/AMPLE WATER. SKIN:WASH SOAP & WATER.
INHL:REMOVE TO FRESH AIR. GIVE ART RESP OR O*2 IF REQD. INGEST:IF
CONSC, GIVE MILK OR WATER. NOTHING BY MOUTH IF UNCONSC. CALL
PHYSICIAN IF SYMP TOMS PERSIST.
===================== Fire Fighting Measures =====================
Flash Point:38C/100F PMCC
Extinguishing Media:SAND,FOAM,CARBON DIOXIDE,DRY CHEMICAL
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING INCL
SLF-CONTAINED BREATHING APPARATUS. TOXIC GASES DURING FIRE FROM
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT W/ABSORBENT INTO CONTAINERS FOR
DISPOSAL. WASH REMAINDER TO SEWER W/AMPLE WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE UNDER 122F. AVOID EXTREME HEAT &
IGNITION SOURCES.
Other Precautions:NONE GIVEN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NONE REQUIRED
Other Protective Equipment:EYEWASH FOUNTAIN, SAFETY SHOWER.
Supplemental Safety and Health
UNDATED MSDS RECD 16DEC85.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:=153.3C, 308.F
Vapor Pres:4
Spec Gravity:0.818
Solubility in Water:NEG
Appearance and Odor:COLORLESS LIQUID, FAINT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:EXTREME HEAT, IGNITION SOURCES
Hazardous Decomposition Products:CARBON, SILICON OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR LANDFILL IAW ALL LAWS & REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P/N 2300-3, ANTI-ABRASIVE COMPOUND
CAGE:18354
CAGE:18354
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:DIETHYLENE GLYCOL MONOETHYL ETHER
CAS:111-90-0
RTECS #:KK8750000
Other REC Limits:NONE SPECIFIED
Ingred Name:VINYL CHLORIDE COPOLYMER (SARA III)
CAS:75-35-4
RTECS #:KV9275000
Other REC Limits:NONE SPECIFIED
ACGIH TLV:5 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:PRECIPITATE OF LEAD CHROMATE
Other REC Limits:NONE SPECIFIED
Ingred Name:PRECIPITATE OF LEAD SULPHATE
Other REC Limits:NONE SPECIFIED
Ingred Name:TOLUIDENE RED
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:UNKNOWN OSHA:NO
Health Hazards Acute and Chronic:INHALATION OF VAPORS ABOVE TLV CAN
PRODUCE LOCAL IRRITATION IN CENTRAL NERVOUS SYSTEM. LOW TO MEDIUM
CONC WILL PRODUCE IRRITATION. HIGH CONC--CENTRAL NERVOUS SYSTEM
DEPRESSION. EYE: IRRITATION. SKIN:IRRITATION LEADING TO
DERMATITIS ON PROLONGED CONTACT. INGESTION: LOCAL IRRITATION TO
MUCOUS MEMBRANES OF MOUTH, THROAT.
Medical Cond Aggravated by Exposure:CENTRAL NERVOUS SYSTEM DEPRESSION.
CONTAINS MANGANESE, PROLONGED EXPOSURE MAY CAUSE DELAYED EFFECTS
INVOLVING THE NERVOUS AND RESPIRATORY SYSTEM.
======================= First Aid Measures =======================
First Aid:IMMEDIATELY REMOVE FROM CONTAMINATED AREA TO FRESH AIR. GIVE
OXYGEN. USE MOUTH TO MOUTH RESUSCITATION. WASH EFFECTED AREA WITH
SOAP. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, ABC DRY CHEMICAL, AIR FOAM (ONLY IF
WATER EVAPORATED).
Unusual Fire/Explosion Hazard:TREAT AS FLAME RETARDENT LATEX FOR
COATING. IF WATER EVAPORATED OFF, DRY POLYMER COULD BURN, POSITIVE
PRESSURE SELF-CONTAINED BREATHING APPARATUS MUST BE USED.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP FLOW OF PRODUCT. AVOID INHALATION OF
VAPORS AND SKIN CONTACT. REMOVE SOURCE OF IGNITION. RESPIRATORY
PROTECTIVE EQUIPMENT MUST BE WORN IN CONFINED AREAS.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE AS A FLAMMABLE LIQUID. AVOID
INHALATION OF VAPORS. STORE IN A COOL PLACE AWAY FROM IGNITION
SOURCES. KEEP AWAY FROM OXIDIZING AGENTS.
Other Precautions:STORE IN A COOL DRY AREA WITH ADEQUATE VENTILATION.
STORAGE VESSELS MUST BE PROPERLY VENTED AND GROUNDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AT A CONCENTRATION EXCEEDING TLV, APPROVED
CANISTER (GAS MASKS).
Ventilation:LOCAL EXHAUST. MECHANICAL (GENERAL): USE ADEQUATE
VENTILATION TO KEEP VAPOR CONCENTRATION BELOW APPLICABLE STANDARDS.
Work Hygienic Practices:WASH HAND WITH SOAP AND WATER. AVOID REPEATED
CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:235F,113C
Spec Gravity:1.18
Solubility in Water:COMPLETE/WTR DILUTBL
Appearance and Odor:OLIVE DRAB GREEN, SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS OR CHLORINE COMPOUNDS.
Stability Condition to Avoid:DO NOT STORE OR MIX WITH OXIDIZING AGENTS
OR CHLORINE COMPOUNDS.
Hazardous Decomposition Products:MAY PRODUCE CARBON MONOXIDE/DIOXIDE.
Conditions to Avoid Polymerization:HEAT, SPARKS, OPEN FLAME. TREAT AS A
FLAMMABLE VINYL COATING SOLUTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:USE ABSORBENT MATERIAL AND DISPOSE OF IN A
CLOSED CONTAINER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GLUCOSE-6-PHOSPHATE DEHYDROGENASE CONTROL NORMAL
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:GLUCOSE-6-PHOSPHATE DEHYDROGENASE CONTROL DEFICIET
CAS:9001-40-5
Fraction by Wt: 5-11%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE: MAY BE HARMFUL BY
INHALATION,INGESTION OR SKIN ABSORPTION; PROLONGED EXPOSURE MAY
CAUSE ALLERGIC REACTIONS IN CERTAIN SENSITIVE INDIVIDUALS. THE
TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHL Y INVESTIGATED.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE CONTACT:FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST
15 MINUTES. ASSURE ADEQUATE FLUSHING BY SEPARATING THE EYELIDS WITH
FINGERS. CALL A PHYSICIAN. SKIN CONTACT: FLUSH WITH COPIOUS AMOUNTS
OFWATER FOR AT LEAST 15 MINUTES. REMOVE CONTAMINATED CLOTHING.
CALL A PHYSICIAN. INHALATION: REMOVE TO FRESH AIR. CALL A
PHYSICIAN. INGESTION: WASH OUT MOUTH WITH WATER IF CONSCIOUS. CALL
A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR APPROPRIATE
FOAM, WATER SPRAY
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
FOR DISPOSAL. AVOID RAISING DUST. VENTILATE AREA & WASH SPILL SITE
AFTER MATERIAL PICK-UP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE CAUTIOUSLY AS THIS MATERIAL IS
POTENTIALLY BIOHAZARDOUS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH-MSHA APPROVED RESPTRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AND FACE THOROUGHLY AFTER EACH USE
OF THIS PRODUCT.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:COMPLETE
Appearance and Odor:SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NATURE OF DECOMPOSITION PRODUCTS NOT
KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH
EXISTING DISPOSAL PRACTICES EMPLOYED FOR INFECTIOUS WASTE AT YOUR
INSTALLATION. OBSERVE ALL FEDERAL, STATE & LOCAL ENVIRONMENTAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:#D1502; DL-2-3-AMINOPROPIONIC ACID MONOHYDR
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:2-3-DIAMINOPROPIONIC ACID MONOHYDROCHLORIDE CRYSTALLINE
CAS:54897-59-5
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF
EYES,SKIN,RESPIRATORY OR G,I.TRACT;REDNESS OR BURNS OF EYES ARE
POSSIBLE.HARMFUL IF INHALED OR INGESTED.NO OTHER IS AVAILABLE.
Explanation of Carcinogenicity:DATA PER MGF MSDS.
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS MAY BE
WORSEN.
======================= First Aid Measures =======================
First Aid:EYES AND SKIN:FLUSH WITH LARGE AMOUNT OF WATER FOR ABOUT
15-20 MINUTES;SEEK MEDICAL ATTENTION IMMEDIATELY.INHALATION:REMOVE
TO FRESH AIR;CALL A PHYSICIAN.INGESTION:SEEK MEDICAL ATTENTION
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;SWEEP UP OR
VACUUM AND COLLECT FOR PROPER DISPOSAL IN AN APPROVED CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AND WELL VENTILATED
AREA.KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:WASH THOROUGHLY AFTER EACH USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR DUST/MIST
IF ABOVE PEL/TLV OR SCBA IN AN ENCLOSED AREA.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:PROTECTIVE CLOTHINGS.EYE-WASH
FACILITIES,SAFETY SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST/DUST.WASH THOROUGHLY AFTER EACH USE.
Supplemental Safety and Health
DO NOT TAKE INTERNALLY.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:450F,232C
Appearance and Odor:WHITE CRYSTALLINE POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:TOXIC OXIDES OF CO,CO*2,NITROGEN
OXIDES,HCL
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES;DISPOSAL MUST BE IN
ACCORDANCE WITH LOCAL,STATE AND FEDERAL REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VORTEX, ORGANIC SOLVENT DEGREASER
CAGE:8S927
CAGE:0WU71
CAGE:8S927
============= Composition/Information on Ingredients =============
Ingred Name:D-LIMONENE
CAS:5989-27-5
Fraction by Wt: >90%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION-MAY CAUSE GASTROINTESTINAL
IRRITATION. INHALATION-ASPIRATION INTO LUNGS MAY CAUSE INJURY.
EYES-EXPOSURE TO HIGH CONCENTRATION OF VAPORS MAY CAUSE SLIGHT
TEMPORARY IRRITATION. SKIN-PROLONGED OR REPEATED EXPOSURE MAY
CAUSE SKIN IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION-MAY CAUSE NAUSEA, VOMITING.
INHALATION-EXCESSIVE INHALATION OF VAPORS MAY CAUSE DIZZINESS OR
HEADACHE. SKIN-PROLONGED OR REPEATED EXPOSURE MAY CAUSE RASHES OR
DEFATTING. REPEATED LONG-TERM C ONTACT MAY CAUSE EXCESSIVE DRYING
OR FLAKING OF SKIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGESTION-DO NOT INDUCE VOMITING. GIVE WATER OR MILK. CALL A
PHYSICIAN IMMEDIATELY. INHALATION-REMOVE TO FRESH AIR. IF BREATHING
IS DIFFICULT, GIVE OXYGEN, CALL PHYSICIAN. EYES-IRRIGATE
IMMEDIATELY WI TH WATER FOR AT LEAST 15 MINUTES. CALL A PHYSICIAN.
SKIN-WASH OFF IN FLOWING WATER OR SHOWER USING SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING AND WASH BEFORE RESUE.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:119F,48C
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE OR DRY CHEMICALS.
Fire Fighting Procedures:DO NOT USE WATER. WEAR SELF-CONTAINED NIOSH
APPROVED, BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NON-TOXIC AND TOXIC FUMES MAY FORM UPON
COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: REMOVE ALL SOURCES OF IGNITION.
ABSORB LIQUID ON VERMICULITE, OR OTHER ABSORBENT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS AWAY FROM
HEAT OR SOURCES OF IGNITION AND OXIDIZING MATERIAL. KEEP OUT OF
REACH OF CHILDREN.
Other Precautions:TREAT AS COMBUSTIBLE LIQUID. AS WITH ANY COMBUSTIBLE
OIL OR SOLVENT, ALL RAGS USED IN CONJUNCTION WITH THIS PRODUCT MUST
BE PLACED IN AMETAL SEALABLE CONTAINER AFTER USE TO AVOID THE
POSSIBLITY OF SPO NTANEOUS COMBUSTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WITH NORMAL USE.
Ventilation:NONE REQUIRED.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:USE WITH ADEQUATE VENTILATION. WASH HNADS AFTER
USE.
Supplemental Safety and Health
ALWAYS KEEP CONTAINER CLOSED. OTHER PRECAUTIONS: READ LABEL BEFORE USE.
AVOID EXCESSIVE CONTACT WITH FUMES OR LIQUID.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:330F,166C
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:<1 MMHG
Vapor Density:>1 AIR=1
Spec Gravity:0.844
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:EMULSIFIABLE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH MILD CITRUS ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:OXIDES OF CARBON MAY BE FORMED UPON
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:TREAT AS SIMPLE OIL WASTE. INCINERATE OR
LANDFILL IN MANNER CONFORMING TO STATE, FEDERAL AND LOCAL REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MOBIL DELVAC 1310
CAGE:3U728
CAGE:3U728
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL/64742-54-7/64741-88-4 (ONE OR MORE OF THESE
PETROLEUM DISTILATES)
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: > 85.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:ADDITIVES (ONE OR MORE OF ALKYL AMIDE,CA ALKARYL
SULFONATE/PHENATE,ZINC DITHIOPHOSPHATE,POLYOLEFIN ESTER,68649-42-3)
Fraction by Wt: < 15.0%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-SKIN:PROLONGED OR REPEATED
CONTACT MAY CAUSE SLIGHT IRRITATION.EYE:SLIGHT
IRRITATION.INHALATION:MISTS MAY CAUSE IRRITATION OF THE RESPIRATORY
TRACT,DIZZINESS,NAUSEA OR UNCONSCIOUSNESS.INGESTION:
UNKNOWN.CHRONIC:MAY CAUSE DERMATITIS.
Effects of Overexposure:SLIGHT IRRITATION OF EYES AND SKIN.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS MATERIAL.
======================= First Aid Measures =======================
First Aid:OBTAIN MEDICAL HELP.INHALATION:REMOVE TO FRESH AIR.GIVE CPR
IF NEEDED.EYE:FLUSH WITH WATER.SKIN:WASH WITH SOAP &
WATER.INGESTION:NOT EXPECTED TO BE A PROBLEM.IF > 0.5 LITER
INGESTED & PATIENT IS CONSC IOUS,IMMEDIATELY GIVE 1-2 GLASSES OF
WATER & GET MEDICAL ADVICE.DO NOT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:>390F,>199C
Lower Limits:0.6
Upper Limits:7.0
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.WATER OR FOAM MAY CAUSE FROTHING.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA WITH ORGANIC VAPOR
FILTER & FULL PROTECTIVE EQUIPMENT. USE WATER SPRAY TO COOL NEARBY
CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN AND DIKE WITH INERT MATERIAL (FULLERS
EARTH,SAND,OIL DRY,ETC.).PREVENT MATERIAL FROM GETTING INTO SEWERS
AND OPEN BODIES OF WATER.USE VACUUM TRUCK OR PUMP TO REMOVE
MATERIAL.TAKE UP SMALL SPIL LS WITH AN ABSORBENT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,VENTILATED AREA
AWAY FROM FLAME & HEAT.KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:MINIMIZE SKIN CONTACT.WASH WITH SOAP & WATER BEFORE
EATING OR DRINKING.LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. THIS
IS AN OIL. KEEP OUT OF SURFACE WATERS AND SEWERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NON REQUIRED UNDER NORMAL CONDITIONS AND
ADEQUATE VENTILATION. IF UNUSUAL CONDITION, USE NIOSH APPROVED SELF
CONTAINED BREATHING APPARATUS WITH ORGANIC VAPORS FILTER.
Ventilation:ADEQUATE VENTILATION
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>600F,>316C
Vapor Pres:<0.1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BROWN LIQUID - MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HIGH TEMPERATURES AND FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE AND METAL OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
IN COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.PRODUCT IS
SUITABLE FOR BURNING IN AN ENCLOSED,CONTROLLED BURNER FOR FUEL
VALUE.SPILLS THAT REACH ES ANY WATERWAY SHOULD BE
REPORTED:1-800-424-8802.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:PLUS 5 CARPET SHAMPOO
Preparer's Name:THOMAS J MITCHELL
CAGE:23212
CAGE:23212
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN/EYE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MAY CAUSE SKIN & EYE IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH OFF IN FLOWING
WATER/SHOWER. INGESTION: INDUCE VOMITING IF LARGE AMOUNTS ARE
INGESTED. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER INTO SANITARY SEWER SYSTEM.
======================Handling and Storage ======================
Other Precautions:AVOID SKIN & EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:GENERAL SHOULD BE SUFFICIENT. LOCAL MAY BE NECESSARY FOR
SOME OPERATIONS.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:18
Spec Gravity:1.058
pH:9.5-10
Evaporation Rate & Reference:(BU AC=1):<1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR YELLOW LIQUID W/BANANA FRAGRANCE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL, ACIDS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:YELLOW ZINC CHROMATE PRIMER, 00-0016-0396
CAGE:59581
CAGE:59581
============= Composition/Information on Ingredients =============
Ingred Name:ING 15: ANIMAL TEST STUDIES HAVE SHOWN POSS EFTS TO LIVER,
KIDNEYS & LUNGS. REPORTS OF ANIMAL TEST STUDIES HAVE (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: SHOWN EMBRYO/FETOTOX EFTS. ETHYL BENZENE:
PRLNGD/RPTD EXPOS CAN CAUSE IRRIT, DEFAT & DERM. TOLUENE: (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: APPEARS ON THE NAVY LIST OF OCCUP CHEM REPRO HAZS.
SEEK CONSULTATION FROM APPROP HEALTH PROFESSIONALS (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG &
EXPOS INFO . ANIMAL STUDIES HAVE SHOWN THAT INHAL (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: OF TOLUENE PRODUCED CARD SENSIT. ACETONE:
RPTD/PRLNGD CONTACT OF LIQ W/SKIN CAN CAUSE REDNESS & DRY (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: SCALY & FISSURED DERM. WHEN ACETONE WAS ABSORBED
SYSTEMICALLY, IT CAUSED CATARACTS IN LAB ANIMALS. (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: METHYL ALCOHOL: TOX EFTS FROM RPTD OVEREXP ARE
ACCUMULATIVE & AFFECT CNS, ESP THE OPTIC NERVE. MAY BE (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22: FATAL OR CAUSE BLINDNESS IF INGESTED. CANNOT BE
MADE NON-POISONOUS. CAN AFFECT BODY THRU INHAL/INGEST/ (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: RPTD/PRLNGD SKIN ABSORPTION. LIVER DMG HAS RSLTD
FROM PRLNGD/RPTD INHAL OF VAPS. ISOPROPYL ALCOHOL: (ING 25)
RTECS #:9999999ZZ
Ingred Name:ING 24: DAMAGES DEVELOPING FETUS.
RTECS #:9999999ZZ
Ingred Name:ZINC CHROMATE
CAS:13530-65-9
RTECS #:GB3290000
Fraction by Wt: 6.72%
OSHA PEL:0.1 MG/M3 (CRO3)
ACGIH TLV:0.01 MG/M3 (CR)
Ingred Name:METHANE, DICHLORO-; (METHYLENE CHLORIDE) (SARA 313)
(CERCLA)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 23.40%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL ALCOHOL; (DENATURED ETHYL ALCOHOL) LEL: 3.30%
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 3.68%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:XYLENE (SARA 313) (CERCLA)LEL: 1.00%
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5.62%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM; 150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENE, ETHYL-; (ETHYL BENZENE) (SARA 313) LEL: 1.20%
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 1.41%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM; 125 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPYLENE OXIDE (SARA 302/313) (CERCLA) LEL: 2.80%
CAS:75-56-9
RTECS #:TZ2975000
Fraction by Wt: 0.12%
OSHA PEL:100 PPM
ACGIH TLV:20 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:TOLUENE (SARA 313) (CERCLA) LEL: 1.27%
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10.70%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE (SARA 313) (CERCLA) LEL: 2.60%
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 14.09%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM; 1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHANOL; (METHYL ALCOHOL) (SARA 313) (CERCLA) LEL: 6.00%
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 0.17%
OSHA PEL:200 PPM, S
ACGIH TLV:200 PPM; 250 STEL, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS) LEL:
0.70%
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 1.11%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ISOPROPYL ALCOHOL (SARA 313) LEL: 2.00%
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 0.38%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 500 STEL
Ingred Name:PROPANE LEL: 2.30%
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15.0%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE) LEL: 1.90%
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 10.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EFTS OF OVEREXP: STUDIES, IT HAS BEEN SHOWN NOT TO
INTERFERE W/REPRODUCTION. XYLENE:HEALTH STUDIES HAVE SHOWN (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: MANY PETROLEUM HYDROCARBONS POSE POTENTIAL HLTH
RISK WHICH MAY VARY FROM PERSON TO PERSON. REPORTS OF (ING 16)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL:EXPOS TO SOLV VAPS CONC
EXCEEDING ESTABLISHED EXPOS LIM VALUES CAN CAUSE RESP SYS IRRIT.
SYMPS OF OVEREXP ARE IRRIT, HDCH, DIZZ, NAUS, POSS UNCON & ASPHY.
EYE:MAY CAUSE EYE IRRIT ESP ON D IRECT CNTCT W/SPRAY.
SKIN:PRLNGD/RPTD LIQ CNTCT MAY CAUSE DEFAT OF SKIN LEADING TO IRRIT
& DERM. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:ZINC CHROMATE: IARC MONOGRAPHS ON THE
EVAL OF CARCIN RISK OF CHEMS TO MAN, VOL 49, PG 49, 1990:GROUP 1.
NTP 7TH (SUPDAT)
Effects of Overexposure:HLTH HAZ: INGEST:ACCIDENTAL INGEST IS UNLIKELY
FROM AEROSOL CAN. IF INGESTED, CALL MD IMMED. CHRONIC:ZINC
CHROMATE:STOM CRAMPS. METHYLENE CHLORIDE:EXCESS EXPOS MAY CAUSE
CARBOXYHEMOGLOBINEMIA, THEREBY IMPAIRING BLOOD'S ABILITY TO
TRANSPORTOXYGEN. EXCESS EXPOS MAY CAUSE CNS/LIVER/KIDNEY EFTS. IN
ANIMAL (ING 14)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE PATIENT TO FRESH AIR. IF BREATHING STOPS, BEGIN
ARTIFICIAL RESPIRATION. SEEK IMMEDIATE MEDICAL ATTENTION. EYES:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES. GET M EDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER.
INGEST: CALL MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:-10F,-23C
Lower Limits:SEE INGREDS
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP. WATER
SPRAY MAY BE INEFTIVE. WATER MAY BE USED TO COOL CNTNRS TO PVNT
BURSTING. IF WATER IS USED, FOG NOZZS ARE PREF.
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT MAY CAUSE BURSTING OF
AEROSOL CAN.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. VENTILATE AREA. WIPE UP WITH INERT MATERIALS AND
PLACE IN APPROPRIATE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. EXPOSURE TO
HEAT OR PROLONGED EXPOSURE TO SUN MAY CAUSE BURSTING.
Other Precautions:USE ONLY AS DIRECTED. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING VAPORS AND INHALING CONTENTS CAN BE
HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID CONTINUOUS BREATHING OF VAPORS AND SPRAY
MIST. NIOSH APPROVED SELF CONTAINED BREATHING APPARATUS REQUIRED
FOR CONCENTRATIONS ABOVE TLV LIMITS.
Ventilation:USE WITH ADEQUATE VENTILATION SUFFICIENT TO PREVENT
INHALATION OF SOLVENT VAPORS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN: ANNUAL RPT ON CARCINS, 1994:KNOWN TO BE CARCIN.
ANIMAL:LUNGS. METHYLENE CHLORIDE:IARC MONOGRAPHS, SUPP, VOL 7, PG
194, 1987:GROUP 2B. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC TO BE
CARCIN. ANIMAL:LUNG, LIVER, SALIVARY, MAMMARY GLAND (TUMORS).
================== Physical/Chemical Properties ==================
Vapor Pres:40 PSIA
Vapor Density:HVR/AIR
Spec Gravity:0.849
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:85.7WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:DO NOT STORE ABOVE 120F. KEEP FROM SPARKS,
PILOT LIGHTS OR OPEN FLAME.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION. FUMES MAY CONTAIN CARBON DIOXIDE AND/OR
CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE AEROSOL. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT PLACE
AEROSOL CANS IN HOME COMPACTOR. DO NOT PUNCTURE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KA1-E1-CP-125-000-005A1A1 PATCH KIT, PART C
Kit Part:Y
Preparer's Name:C G HUTTER
CAGE:66530
CAGE:66530
============= Composition/Information on Ingredients =============
Ingred Name:1,1,1-TRICHLOROETHANE (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 95%
Other REC Limits:NONE SPECIFIED
OSHA PEL:350 PPM
ACGIH TLV:350 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:DIETHYLENE ETHER (SARA III)
CAS:123-91-1
RTECS #:JG8225000
Fraction by Wt: 2.5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:S, 100 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:BUTYLENE OXIDE (SARA III)
CAS:109-99-9
RTECS #:LU5950000
Fraction by Wt: 0.4%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NITRO METHANE
CAS:75-52-5
RTECS #:PA9800000
Fraction by Wt: 0.3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES-PAIN AND IRRITATION.
SKIN-PROLONGED EXPOSURE MAY CAUSE IRRITATION. INHALATION-ANESTHETIC
OR NARCOTIC EFFECTS AT 500-1000 PPM.
Effects of Overexposure:DIZZINESS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN CONDITIONS.
======================= First Aid Measures =======================
First Aid:WASH WITH WATER, REMOVE TO FRESH AIR, DO NOT INDUCE VOMITING,
CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:7.5
Upper Limits:12.5
Extinguishing Media:WATER FOG.
Fire Fighting Procedures:PRESSURE DEMAND, SELF-CONTAINED RESPIRATORY
EQUIPMENT.
Unusual Fire/Explosion Hazard:AT HIGH TEMPERATURES PRODUCT DECOMPOSES
TO GIVE OFF HYDROCHLORIC ACID GAS AND PHOSGENE.
================== Accidental Release Measures ==================
Spill Release Procedures:GATHER UP POUCHES AND PLACE IN WASTE CONTAINER
TO AWAIT DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT TAKE INTERNALLY. DO NOT GET IN
EYES. WASH THOROUGHLY AFTER HANDLING.
Other Precautions:DO NOT USE TO CLEAN PARTS OF BODY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:GENERAL
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:165F,74C
Vapor Pres:100 MM HG
Spec Gravity:1.25 (WATER=1)
Evaporation Rate & Reference:0.37
Appearance and Odor:1 BLUE TOWELETTE IN CLEAR LIQUID FILLED POUCH.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:OPEN FLAME, WELDING ARCS, HIGH TEMPERATURE
SOURCES.
Hazardous Decomposition Products:HYDROCHLORIC ACID, PHOSGENE GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOR UPOPENED POUCHES CONTAINING LIQUID MATERIAL,
DISPOSE OF AS HAZARDOUS WASTE SUBJECT TO SPECIFIC REGULATIONS. FOR
OPEN POUCHES AND DRY TOWELETS, DISPOSE OF AS SOLID WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENPLATE CU-406 C, 3319
Preparer's Name:S. D. KOCH
CAGE:02258
CAGE:02258
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: <10%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >90%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL:MIST OR VAPOR MAY
IRRITATE RESPIRATORY TRACT. INGEST:CAN CAUSE SEVERE IRRITATION TO
MOUTH, THROAT, ESOPHAGUS & STOMACH. SKIN:CAN CAUSE IRRITATION.
EYES:CAN CAUSE SEVERE IRRITATION & DAMAG E TO EYES. CHRONIC:
NAUSEA, VOMITING, DISTURBANCES OF DIGESTIVE TRACT, CHROME SORES,
BONE FLUOROSIS & (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:POSSIBLY OSTEOSCLEROSIS & LUNG CANCER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM CONTAMD AREA. IF BRTHG HAS STOPPED,
RESUSCITATE & ADMIN OXYGEN IF AVAIL. SEEK IMMED MED ATTN.
INGEST:NEVER GIVE ANYTHING BY MOUTH TO UNCON PERS. OBTAIN IMMED MED
ATTN. IF VOM OCCURS SPONT, KEEP AIRWAY CLEAR. IF SWALLOWED,DO NOT
INDUCE VOM. GIVE LGE AMTS OF WATER. SEEK IMMED MED ATTN. SKIN:IMMED
WASH W/PLENTY OF WATER FOR 15 MINS. REMOVE CONTAMD CLTHG/FOOTWEAR.
WASH (SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER FOG OR SPRAY, CARBON DIOXIDE OR FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . KEEP CONTAINERS COOL TO PREVENT RUPTURE &
RELEASE OF MATERIAL.
Unusual Fire/Explosion Hazard:MAY REACT W/AMPHOTERIC METALS (SUCH AS
ZINC & ALUMINUM) GENERATING HYDROGEN GAS WHICH WILL BURN OR EXPLODE
IF IGNITED.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CONT W/SKIN, EYES & CLOTHING. WEAR PROT
EQUIP. DO NOT BREATHE MIST/VAPORS. CONTAIN SPILL & SOAK UP IN
SUITABLE ABSORB. SHOVEL UP INTO PLASTIC LINED STEEL CONTRS. DILUTE
RESIDUAL MATL W/COPIOUS A MTS OF WATER & NEUT. FOR MAJOR SPILLS
(SUP DAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP AWAY
FROM STRONG ACIDS. LOOSEN COVER CAUTIOUSLY WHEN OPENING. STORE
ABOVE FREEZING TEMPERATURE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WHEN AIR
CONCENTRATION IS GREATER THAN THE TLV OR PEL. USE NIOSH/MSHA
APPROVED CARTRIDGE FILTER FOR ALKALINE MIST.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:CHEMICALLY RESISTANT COVERALLS, HAT & SHOES
OR BOOTS. EMERGENCY EYEWASH & SAFETY SHOWER SHOULD BE AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRST AID PROC:CLTHG BEFORE REUSE. DISCARD FOOTWEAR IF IT CANNOT BE
DECONTAMD. SEEK IMMED MED ATTN. EYES:FLUSH W/PLENTY OF WATER FOR AT
LEAST 15 MINS, HOLDING LIDS APART TO ENSURE FLUSHING OF ENTIRE S
URF TO PVNT/RELIEVE IRRIT. IF IRRIT PERSISTS, SEEK MED ATTN. SPILL
PROC:CONSULT ENTHONE-OMI FOR DISPOSAL ASSISTANCE.
================== Physical/Chemical Properties ==================
HCC:C2
Boiling Pt:B.P. Text:215F,102C
Melt/Freeze Pt:M.P/F.P Text:26.0F,-3.3C
Spec Gravity:1.023 (H*2O=1)
pH:CA 13
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TRACES OF OXIDES OF NITROGEN, SULFUR &
CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOR WASTE DISPOSAL OF OPERATING SOLUTIONS,
CONSULT ENTHONE-OMI WASTE DISPOSAL PROCEDURES. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P/N M8002 RECHARGEABLE NICKEL CADMIUM CELLS
CAGE:57932
CAGE:57932
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM OXIDE (SARA III)
CAS:1306-19-0
RTECS #:EV1925000
Fraction by Wt: 8-15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1027
ACGIH TLV:0.05 MG(CD)/M3; 9293
Ingred Name:CADMIUM HYDROXIDE
Fraction by Wt: 8-15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3 (CD FUME)
ACGIH TLV:0.05 MG/M3 (CD FUME)
Ingred Name:NICKEL HYDROXIDE (SARA III)
CAS:12054-48-7
RTECS #:QR7040000
Fraction by Wt: 3-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG NI/M3
ACGIH TLV:0.1 MG NI/M3; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 2-4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LITHIUM HYDROXIDE
Fraction by Wt: <0.4%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:BATTERY NOT HEALTH HAZARD UNLESS CASE
BROKEN. ACUTE: INHALATION OF ELECTROLYTE VAPORS MAY IRRITATE
RESPIRATORY SYSTEM. SKIN AND EYE CONTACT WITH ELECTROLYTE MAY CAYSE
BURNS OR SEVERE IRRITATION. INGES TION OF ELCETROLYTE MAY CAUSE
SEVERE GITRACT IRRITATION AND BURNS TO MOUTH, THROAT AND ESOPHAGUS.
CHRONIC: UNKNOWN.
Explanation of Carcinogenicity:NICKEL IS LISTED AS A CARCINOGEN BY NTP
AND IARC.
Effects of Overexposure:INHALED: COUGHING, WHEEZING, SHORTNESS OF
BREATH, CHEST PAIN. EYES: BURNS, PAIN, TEARING, BLUURED VISION.
SKIN: REDNESS, BURNS, PAIN, BLISTERS. INGESTED: SEVERE STOMACH
PAIN, NAUSEA, VOMITING, BURNS T O MOUTH, THROAT AND ESOPHAGUS.
======================= First Aid Measures =======================
First Aid:INHALED: REMOVE TO FRESH AIR. SEE DOCTOR IF SYMPTOMS PERSIST.
EYES: FLUSH WITH LOTS OF WATER FOR 15 MINUTES. SEE DOCTOR. SKIN:
REMOVE CONTAMINATED CLOTHES. RINSE WITH LOTS OF WATER. SEE DOCTOR
IF BURN ED. INGESTED: DO NOT INDUCE VOMITING UNLESS DIRECTED BY
MEDICAL PERSONNEL. IF CONSCIOUS, GIVE WATER TO DILUTE. GET
IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER. HMIS: WEAR
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE ANY SPILLED ELECTROLYTE WITH 5%
ACETIC ACID SOLUTION. SCOOP UP AND PLACE IN A CONTAINER FOR LATER
DISPOSAL. DO NOT ALLOW SPILLED ELECTROLYTE TO ENTER SEWER OR
WATERWAYS.
Neutralizing Agent:5% ACETIC ACID SOLUTION
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
COMBUSTIBLE MATERIALS UNLESS IN ORIGINAL PACKAGING. PROTECT FROM
PHYSICAL DAMAGE.
Other Precautions:DO NOT STACK MORE THAN 4 LAYERS HIGH ON PALLET AND NO
MORE THAN 3 PALLETS HIGH. DO NOT INCINERATE OR SUJECT CELLS TO
TEMPERATURES IN EXCESS OF 212F (100C); MAY CAUSE CELL EXPLOSION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER. HMIS: NONE
NORMALLY REQUIRED.
Ventilation:NONE SPECIFIED BY MANUFACTURER. HMIS: USE ADEQUATE
MECHANICAL VENTILATION.
Other Protective Equipment:HMIS: SPILL- RUBBER APRON, BOOTS. SAFETY
SHOWER AND EYE WASH AVAILABLE IN CASE OF SPILL.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
FULL ENCAPSULATION (POTTING) OF THESE BATTERIES WILL PREVENT PROPER
OPERATION OF THE RESEALABLE SAFETY VENT IF INTERNAL PRESSURE
EXCEEDS THE DESIGN LIMIT RESULTING IN EXPLOSION.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:SEALED BATTERY, 2.5 X 5.6 X 0.6 INCHES. 13.0 VOLTS,
500 AMP-HOURS; 10 CELLS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:DO NOT SHORT CIRCUIT. TEMPERATURES ABOVE
212F. DO NOT SEAL IN AIRTIGHT OR WATERTIGHT CONTAINERS.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE OR PUNCTURE BATTERIES. DISPOSE
OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AP 15
CAGE:01VT9
CAGE:01VT9
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHORIC ACID (SARA 313) (CERCLA)
CAS:7664-38-2
RTECS #:TB6300000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/3 STEL; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- CORROSIVE. EYE OR SKIN CONTACT MAY CAUSE
CHEMICAL BURNS. MAY CAUSE PERMANENT EYE DAMAGE. INHALING
MIST/VAPORS MAY CAUSE SEVERE RESPIRATORY IRR ITATION & BURNS.
INGESTION MAY CAUSE TISSUE DAMAGE & BURNS TO MOUTH, THROAT &
DIGESTIVE TRACT. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SEVERE IRRITATION, BURNS, DIFFICULTY IN
BREATHING, PAIN, NAUSEA, VOMITING, COUGHING
Medical Cond Aggravated by Exposure:SKIN IRRITATION MAY BE AGGRAVATED
IN PERSONS WITH EXISTING SKIN LESIONS. MISTS MAY AGGRAVATE ACUTE OR
CHRONIC ASTHMA OR OTHER RESPIRATORY DISEASES.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IMMEDIATELY. EYE/SKIN:IMMEDIATELY FLUSH
WITH WATER FOR AT LEAST 15 MINUTES. HOLD EYELIDS OPEN.
INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF NEEDED. ORAL:DO
NOT INDUCE VOMI TING. RINSE MOUTH. DRINK LARGE AMOUNT OF
WATER/MILK. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CAN REACT WITH COMMON METALS TO LIBERATE
FLAMMABLE AND POTENTIALLY EXPLOSIVE HYDROGEN GAS. MAY FORM
HAZARDOUS FUMES SUCH AS PHOSPHORUS OXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENTS INCLUDING
RESPIRATOR FOR ACID MISTS. DIKE SPILL WITH SAND OR CLAY TO KEEP IT
OUT OF SEWER SYSTEM. NEUTRALIZE WITH SODA ASH. REQUIRES GOOD
VENTILATION AS CO2 IS PRODUCED. PLA CE NEUTRALIZED SPILL IN DOT
APPROVED CONTAINER.
Neutralizing Agent:SODA ASH
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS AWAY FROM
HEAT & INCOMPATIBLE MATERIALS.
Other Precautions:WARNING! CORROSIVE. KEEP OUT OF REACH OF CHILDREN. DO
NOT GET IN EYES, ON SKIN OR ON CLOTHING. AVOID BREATHING MISTS OR
VAPORS. WASH THOROUGHLY AFTER HANDLING. DO NOT INGEST. IN HOT
WEATHER, LOOSEN PL UGS. READ LABEL INSTRUCTIONS CAREFULLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH-APPROVED RESPIRATOR FOR ACID MISTS
WHEN HANDLING SPILLS, LEAKS OR WHEN AIRBORNE CONCENTRATIONS EXCEED
EXPOSURE LIMITS.
Ventilation:PROVIDE SUFFICIENT GENERAL OR LOCAL EXHAUST VENTILATION TO
CONTROL INHALATION EXPOSURES BELOW OSHA'S PEL.
Other Protective Equipment:EYE WASH STATION & EMERGENCY SHOWER SHOULD
BE IN CLOSE PROXIMITY. USE OF RUBBERIZED COVERALLS & RUBBER SHOES
SUGGESTED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:C1
NRC/State Lic Num:NOT RELEVANT
Spec Gravity:>1
pH:ACIDIC
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID - ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, REACTIVE METALS
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:TOXIC GASES OF PHOSPHORUS OXIDES MAY
BE FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
NEUTRALIZED SOLUTION MAY BE FLUSHED TO SEWER IF ALLOWED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:987 9178 FERRIC SULFATE (GRANULAR) FOR IMAGE GUARD PROGRAM
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:FERRIC SULFATE
CAS:10028-22-5
RTECS #:NO8505000
Fraction by Wt: 100% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG (FE)/M3
ACGIH TLV:1 MG (FE)/M3; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY CAUSE TRANSIENT EYE IRRITATION. LOW
SKIN CONTACT HAZARD FOR RECOMMENDED HANDLING. EXPECTED TO BE A LOW
INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMEEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSTION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:KEEP AWAY FROM INCOMPATIBLE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE. KEY1:N1.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:DECOMPOSES
Decomp Temp:Decomp Text:896F,480C
Vapor Pres:NEGLIGIBLE
Vapor Density:NEGLIGIBLE
Spec Gravity:3.1
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:APPRECIABLE
Appearance and Odor:GRAY SOLID CRYSTAL, NO ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SULFUR DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. DISPOSE OF IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FURNITURE POLISH C-810
CAGE:GO155
CAGE:31834
CAGE:GO155
============= Composition/Information on Ingredients =============
Ingred Name:L.P.G. (LIQUID PETROLEUM GAS) PROPELLANT(FLAMMABLE)
CAS:68476-85-7
RTECS #:SE7545000
Fraction by Wt: 5%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1800 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR IF CONSCIOUS. EYES: FLUSH
IMMEDIATELY W/LARGE AMOUNTS OF WATER. INGESTION: INDUCE VOMITING.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG, DRY CHEMICAL/CO2
Fire Fighting Procedures:KEEP CONTAINER COOL. USE EQUIPMENT/SHIELDING
AS REQUIRED TO PROTECT PERSONNEL AGAINST BURSTING,
RUPTURING/VENTING CONTAINERS.
Unusual Fire/Explosion Hazard:AT ELEVATED TEMP (>130F) CONTAINERS MAY
VENT, RUPTURE/BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP W/ABSORBENT MATERIAL & DISPOSE AS
W/GASOLINE SOAKED RAGS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE WHERE TEMP >130F.
Other Precautions:FRESHLY SPRAYED FOAM MAY BURN, DON'T SPRAY NEAR FIRE,
SPARKS/RED HOT SURFACES. DON'T WEAR CLOTHING SOAKED BY SPRAY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:MECHANICAL (GENERAL VENTILATION) IF SPRAYING LARGE AMOUNTS.
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:117
Vapor Density:>1
Spec Gravity:0.97
Solubility in Water:MORE THAN 10%
Appearance and Odor:WIDE HOLLOW CONE, SEMI-STABLE FOAM, LEMON ODOR,
RESIDUE IS CLEAR, SHINY COATING
Percent Volatiles by Volume: 90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:TEMP >130F
Hazardous Decomposition Products:CO AT GENERALLY LOW LEVELS
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T PUNCTURE/INCINERATE CONTAINERS. GIVE
EMPTY, LEADING/FULL CONTAINERS TO A DISPOSAL SERVICE EQUIPPED TO
SAFELY HANDLE & DISPOSE OF PRESSURIZED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1069, ASPHALT & TAR REMOVER
CAGE:72674
CAGE:27674
CAGE:72674
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA, LIGHT AROMATIC
CAS:64742-95-6
Fraction by Wt: 40-50%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:BENZENE, O-DICHLORO-; (O-DICHLOROBENZENE) (SARA III)
CAS:95-50-1
RTECS #:CZ4500000
Fraction by Wt: 20-30%
OSHA PEL:C 50 PPM
ACGIH TLV:S, 25PPM/50 STEL9394
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:KEROSENE
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 10-20%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:GLYCOLS, POLYETHYLENE MONO (NONYLPHENYL) ETHER (NONIONIC);
(NONYLPHENOL POLYETHOXATE)
CAS:9016-45-9
RTECS #:MD0905000
Fraction by Wt: <5%
Ingred Name:WASTE DISP METH: OR INDUS WASTE LANDFILL. CONSULT LOCAL,
STATE, AND FEDERAL AGENCIES FOR PROPER DISP METH IN YOUR AREA.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL OF VAP CAN CAUSE CNS
DEPRESS CHARACT BY HDCH, DIZZ, NAUS, STUPOR, UNCON, & IN EXTREME
CASES, DEATH. VAPS MAY ALSO PRDCE EYE, NOSE, & THROAT IRRIT. CARD
SENSIT MAY LEAD TO HEART RHYTHM DIS ORDERS IN SOME INDIV.
INTRODUCTION OF SOLV INTO LUNGS, AS IN ASPIR OF VOMIT FLUIDS, MAY
CAUSE CHEM (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:PNEUM. EXISTING RESP DISORDERS OF SKIN
DISEASES MAY BE AGGRAVATED BY EXPOS. ANIMAL STUDIES INDICATE POTNTL
FOR LIVER & KIDNEY DMG. RELEVANCE OF STUDIES/EXPOS LEVS WHICH MIGHT
PRDCE EFTS IN HU MANS HAS NOT BEEN ESTABLISHED. CHRONIC:RPTD/PRLNGD
SKIN CONT MAY PRDCE MILD CNS DEPRESS, CHARACT BY HDCH,NAUS,
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: WASH CONTAM SKIN THORO W/SOAP & MILD DETERGENT. APPLY
SKIN CREAM W/LANOLIN. GET MED ATTN IF IRRIT PERSISTS. EYES: IMMED
FLUSH EYES W/PLENTY OF H2O FOR AT LST 15 MINS, OCCAS LIFTING UPPER
& LOWER LIDS. GET MED ATTN AT ONCE. INHAL: MOVE EXPOS PERSON TO
FRESH AIR AT ONCE. IF BRTHG HAS STOPPED, PERFORM ARTF RESP. GET MED
ATTN IMMED. INGEST: DO NOT INDCE VOMIT.IF VOMIT OCCURS, KEEP HEAD
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:113F,45C
Lower Limits:2.2%
Upper Limits:9.2%
Extinguishing Media:CO2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONCENTRATED VAPOR MAY IGNITE IF EXPOSED
TO SPARK.
================== Accidental Release Measures ==================
Spill Release Procedures:IMMED ELIMINATE ALL FLAME, IGNITION AND
HIGH-HEAT SOURCES. ABSORB SPILL ON INERT ABSORBENT MATERIAL (E.G.
ZEP-O- ZORB). PICK UP AND PLACE IN CLEAN, DOT SPECIFICATION
CONTAINER FOR DISPOSAL. WASH AREA THOROUGHLY WITH DETERGENT SOLN &
RINSE WELL W/H2O
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:COMBUST! STORE & USE AWAY FROM HEAT,
SPARKS, OPEN FLAME/ANY SOURCE OF IGNIT. VAPS ARE HVR/AIR & WILL
ACCUMULATE AT LOW POINTS.
Other Precautions:VENT SHOULD INCL FLOOR LEV EXHST.FIRE EXPOS DRUMS
SHOULD BE COOLED W/STREAM OF H2O.KEEP PROD AWAY FROM SKIN/EYES.DO
NOT BRTH SPRAY MISTS/VAPS.STORE IN TIGHTLY CLSD CNTNR IN DREAM AREA
AT TEMPS BETWEEN 40-120F.KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION IS INADEQUATE, WEAR NIOSH/MSHA
APPROVED PROPERLY FITTING RESPIRATOR.
Ventilation:VENTILATION SHOULD BE EQUAL TO OUTDOORS. USE EXHAUST FANS
AND/OR EXHAUST HOOD IN ENCLOSED SPACES.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: STUPOR, & COMA.SKIN WHICH IS DEFATTED BY RPTD EXPOS TO
HYDROCARB SOLV IS MORE SUSCEPTIBLE TO IRRIT, INFECTION, & DERM.
ANIMAL STUDIES OF EFTS OF PRLNGD INHAL INDICATED POTNTL FOR LUNG
DMG & BLOOD PRODUCTION ABNORM, SOME OFWHICH WERE FATAL. FIRST AID
PROC:BELOW HIP LEV. GET EMER MED ATTN IMMED.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>260F,>127C
Spec Gravity:1.00
Solubility in Water:EMULSIFIES
Appearance and Odor:DARK BROWN, MODERATELY VISCIOUS LIQUID WITH
MOTHBALL ODOR.
Percent Volatiles by Volume:85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, ALKALIES, AND OXIDIZERS.
Stability Condition to Avoid:HEAT, FLAME, SPARKS.
Hazardous Decomposition Products:CO2, CO, HCL, AND SMALL AMOUNTS OF
PHOSGENE & CHLORINE GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:LIQ CANNOT BE SENT TO LANDFILLS UNLESS
SOLIDIFIED. UNUSABLE PROD & COLLECTED, SPENT MATL MAY REQ DISP AS
HAZ WASTE AT PERMITTED TREATMENT/STOR/DISP FACILITY. IN MOST STATES
HAZ WASTE IN TOTAL AMTS OF220 LBS/LESS PER MONTH MAY BE DISP IN
CHEM (ING 5)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FID TEST MIX
CAGE:55371
CAGE:55371
============= Composition/Information on Ingredients =============
Ingred Name:TETRADECANE
CAS:629-59-4
RTECS #:XB8000000
Fraction by Wt: 0.03%
Other REC Limits:300 NG/UL (MFR)
Ingred Name:PENTADECANE
CAS:629-62-9
RTECS #:RZ1800000
Fraction by Wt: 0.03%
Other REC Limits:300 NG/UL (MFR)
Ingred Name:HEXADECANE
CAS:544-76-3
RTECS #:ML9200000
Fraction by Wt: 0.03%
Other REC Limits:300 NG/UL (MFR)
Ingred Name:PENTANE, 2,2,4-TRIMETHYL-; (ISO-OCTANE). BP:211F. MP:-161F.
SPEC GRAV:0.69 (H*2O=1). VAP DENS:3.9
CAS:540-81-1
RTECS #:SA3320000
Fraction by Wt: 99.91%
Ingred Name:FIRST AID PROC:LOWER LIDS, UNTIL NO EVID OF CHEM REMAINS
(15-20 MINS). GET MED ATTN IMMED. INGEST:TREAT PERS (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:SYMPTOMATICALLY & SUPPORTIVELY. GET MED ATTN & ADVICE
ON WHETHER TO USE GASTRIC LAVAGE. EXTREME CARE MUST (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:BE TAKEN TO PVNT ASPIR. A CUFFED ENDOTRACHEAL TUBE
USED BY QUALIFIED MED PERS MIGHT BE ADVISABLE. KEEP (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:HEAD LOWER THAN HIPS TO PREVENT ASPIRATION SHOULD
VOMITING OCCUR. ANTIDOTE:NO SPEC ANTIDOTE. TREAT PERSON (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:SYMPTOMATICALLY & SUPPORTIVELY.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL:MAY CAUSE PULM IRRIT.
HIGH CONC MAY CAUSE DIZZ, LACK OF COORD, NAUS, NARCOSIS & OTHER CNS
EFTS. IN RATS EXPOSED TO 16,000 PPM FOR 5 MINS, THERE WAS SENSORY
IRRIT & ONE OF FOUR MICE DIED; AT 32,000 PPM, EFTS INCL IRRIT &
IRREG RESPIRATION, & ALL FOUR MICE DIED W/IN 4 MINS. SKIN:MAY CAUSE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:IRRIT. EYES:MAY CAUSE IRRIT.
INGEST:MAY CAUSE CNS EFTS W/SYMPS OF NAUS, DIZZ, LACK OF COORD &
NARCOSIS. ASPIR INTO LUNGS, W/SOME ALKANES, MAY CAUSE CHEM
PNEUMONITIS, PULM EDEMA & HEMORRHAGING . OCTANE ISOMERS APPEAR TO
CAUSE PULM LESIONS IF ASPIRATED INTO LUNGS OF RATS. IN ANIMAL
STUDIES, ASPIR OF (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR IMMED. IF BRTHG HAS STOPPED,
PERFORM ARTF RESP. KEEP PERS WARM & AT REST. TREAT SYMPTOMATICALLY
& SUPPORTIVELY. GET MED ATTN IMMED. SKIN:REMOVE CONTAMD CLTHG/SHOES
IMMED. WAS H W/SOAP OR MILD DETERGENT & LGE AMTS OF WATER UNTIL NO
EVID OF CHEM REMAINS (15-20 MINS). GET MED ATTN IMMED. EYES:WASH
IMMED W/LGE AMTS OF WATER OR NORM SALINE, OCCASNLY LIFTING UPPER &
(ING 5)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:10F,-12C
Lower Limits:1.1%
Upper Limits:6%
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, HALON, WATER SPRAY OR
STANDARD FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS MAY BE EXPLOSIVE. AVOID
OVERHEATING CONTAINER.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF IGNITION SOURCES. STOP LEAK IF YOU
CAN DO IT W/OUT RISK. TAKE UP W/SAND OR OTHER ABSORBENT MATERIAL &
PLACE IN OTHER CONTAINERS FOR LATER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT FROM TEMPERATURE EXTREMES &
DIRECT SUNLIGHT. SHOULD BE STORED IN AN ACCEPTABLY PROTECTED &
SECURE FLAMMABLE LIQUID STORAGE ROOM.
Other Precautions:GROUND & BOND METAL CONTAINER TO MINIMIZE STATIC
SPARKS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR LARGE AMOUNTS, USE NIOSH/MSHA APPROVED SCBA
W/FULL FACEPLATE OPERATED IN PRESSURE-DEMAND MODE.
Ventilation:LOCAL EXHAUST & MECHANICAL (GENERAL).
Other Protective Equipment:EMERGENCY EYE WASH FOUNTAINS & SAFETY
SHOWERS SHOULD BE AVAILABLE IN THE VICINITY OF ANY POTENTIAL
EXPOSURE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:C6-C8 HYDROCARBONS RSLTD IN ALMOST IMMED DEATH DUE TO
RESP PARALYSIS, ASPHYXIA & CARD ARREST. CHRONIC: INHAL:RPTD/PRLNGD
EXPOS TO PARAFFIN HYDROCARBONS MAY CAUSE POLYNEUROPATHY. SKIN:R
PTD/PRLNGD EXPOS TO IRRITANTS MAY CAUSEDERM. EYES:RPTD/PRLNGD EXPOS
TO IRRITANTS MAY CAUSE CONJUNCT. INGEST:NO DATA.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:INGRED 4
Melt/Freeze Pt:M.P/F.P Text:INGRED 4
Vapor Density:INGRED 4
Spec Gravity:INGRED 4
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID W/ODOR OF GASOLINE.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS & REDUCING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, HEAT, SPARKS, FLAMES &
OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:TOXIC OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA HAZARDOUS WASTE NUMBER D001. DISPOSE OF AS
AN EPA HAZARDOUS WASTE. DISPOSAL MUST BE IN ACCORDANCE W/FEDERAL,
STATE & LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MULTIPURPOSE AUTOMATIC TRANSMISSION FLUID
Resp. Party Other MSDS Num.:PACER PRODUCT CODE: 161
CAGE:1L506
Contract Num:SP0450-99-M-B044
CAGE:1L506
============= Composition/Information on Ingredients =============
Ingred Name:DISTILLATES (PETROLEUM), HYDROTREATED HEAVY
PARAFFINIC/LUBRICATING OIL BASE STOCK
CAS:64742-54-7
RTECS #:PY8035500
Minumum % Wt:0.
Maxumum % Wt:90.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:SOLVENT DEWAXED HEAVY PARAFFINIC DISTILLATE
(PETROLEUM)/LUBRICATING OIL BASE STOCK
CAS:64742-65-0
RTECS #:PY8038500
Minumum % Wt:0.
Maxumum % Wt:90.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:NON-HAZARDOUS COMPONENTS
= Wt:10.
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYES, SKIN, RESPIRATORY
AND GASTROINTESTINAL TRACTS. ACUTE - EYE CONTACT MAY CAUSE
IRRITATION. PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE
IRRITATION. INHALATION OF OIL FUMES OR MIST F ROM FLUID MAY CAUSE
RESPIRATORY IRRITATION. INGESTION MAY CAUSE ACUTE STOMACH DISTRESS
AND LUNG DAMAGE IF LARGE QUANTITIES ARE SWALLOWED AND ASPIRATED.
CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:USED MOTOR OILS HAVE BEEN SHOWN TO CAUSE
SKIN CANCER IN MICE FOLLOWING REPEATED APPLICATION AND CONTINUOUS
EXPOSURE.
Effects of Overexposure:IRRITATION, NAUSEA, COUGH, DRY SKIN
Medical Cond Aggravated by Exposure:SKIN DISORDERS
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALATION: REMOVE FROM
SOURCE OF MIST OR VAPOR; PROVIDE FRESH AIR. EYE CONTACT: FLUSH WITH
LARGE AMOUNT OF FRESH WATER. HOLD EYELIDS OPEN. SKIN CONTACT: WASH
THO ROUGHLY WITH SOAP & WATER. REMOVE OIL SOAKED CLOTHING AND
LAUNDER BEFORE REUSE. INGESTION:IF INGESTED, DO NOT INDUCE
VOMITING. SEEK IMMEDIATE MEDICAL ATTENTION. IF VOMITING OCCURS,
KEEP HEAD BELOW HI PS. DO NOT GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. NOTE: IN CASE OF CONTACT WITH HEATED FLUID,
TREAT AS A BURN AND CONTACT A PHYSICIAN, HEALTH CARE PROVIDER, OR
MEDICAL EMERGENCY CLINIC IMMED IATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>93.3C, 200.F
Autoignition Temp:>260.C, 500.F
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:FOAM, DRY CHEMICAL, C02, WATER SPRAY OR FOG
Fire Fighting Procedures:USE AIR SUPPLIED RESCUE EQUIPMENT FOR ENCLOSED
AREAS. COOL EXPOSED CONTAINER WITH WATER
Unusual Fire/Explosion Hazard:DO NOT STORE WITH STRONG OXIDANTS
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE FREE LIQUID. ADD ABSORBENT TO SPILL
AREA. KEEP PETROLEUM PRODUCTS OUT OF STREAMS AND WATERWAYS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED. KEEP
CONTAINERS AWAY FROM HEAT AND FLAME.
Other Precautions:AVOID INHALATION OF OIL FUMES, MIST, OR VAPOR. DO NOT
GET IN EYES. AVOID SKIN CONTACT AND USE PERSONAL PROTECTION WHEN
HANDLING WASTE OILS. REMOVE AND LAUNDER OIL SOAKED CLOTHING BEFORE
REUSE. PROPERL Y DISPOSE OF CONTAMINATED LEATHER ARTICLES INCLUDING
SHOES THAT CANNOT BE DECONTAMINATED. KEEP OUT O F REACH OF
CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, WEAR A
NIOSH-APPROVED ORGANIC MIST/VAPOR CARTRIDGE (YELLOW CODE).
Ventilation:LOCAL EXHAUST TO REMOVE OIL MIST, FUMES, OR VAPORS
Other Protective Equipment:EYE BATH, WASHING FACILITY, LAB COAT OR
UNIFORM.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH AFTER HANDLING AND BEFORE EATING,
DRINKING OR SMOKING.
Supplemental Safety and Health
P/N: DEXRON III.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:>260.C, 500.F
B.P. Text:IBP
Vapor Pres:<0.01 (MM/HG @ 100 DEG F)
Vapor Density:>12.0(100F
Spec Gravity:0.88 (H20=1)
Evaporation Rate & Reference:<0.01 (NBA=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED COLORED LIQUID; CHARACTERISTIC PETROLEUM ODOR
Percent Volatiles by Volume:NEGLIGIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS LIQUID CHLORINE, CONCENTRATED OXYGEN,
SODIUM HYPOCHLORITE OR CALCIUM HYPOCHLORITE
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE, CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE ABSORBED MATERIAL. COMPLY WITH LOCAL,
STATE, AND FEDERAL LAWS AND REGULATIONS. NOTE: NOT REPORTABLE AS
HAZARDOUS WASTE UNDER 40 CFR 261. CONTAINS NO TOXIC POLLUTANTS AS
DEFINED BY 40 CFR 40 1.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:831 3157 POLYMAX T DEVELOPER
Preparer's Name:NONE
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA III)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
Fraction by Wt: 15-20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 50-55%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: IRRITATION. SKIN:
IRRITATION, ALLERGIC SKIN REACTION. INHALATION: LOW HAZARD FOR
RECOMMENDED HANDLING. INGESTION: HARMFUL IF SWALLOWED. CHRONIC: CAN
CAUSE KIDNEY DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION, ALLERGIC
SKIN REACTION. INHALATION: NONE SPECIFIED. INGESTION: KIDNEY
DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. FLUSH AREA WITH
LARGE AMOUNTS OF WATER AND WASH WITH NON-ALKALINE (ACID) TYPE SKIN
CLEANER. IF IRRIT ATION OR ALLERGIC REACTIONS DEVELOP GETMEDICAL
ATTENTION. INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET
MEDICAL ATTENTION IF SYMPTOMS PERSIST. INGESTION: INDUCE VOMITING.
GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
MAY REQUIRE NEUTRALIZATION IF PH <3 OR >12. OTHERWISE, ABSORB WITH
VERMICULITE OR OTHER INERT MATERIAL, THEN PLACE IN CONTAINER FOR
CHEMICAL WASTE. CLEAN SU RFACE THOROUGHLY TO REMOVE RESIDUAL
CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED AND AWAY
FROM CONTACT WITH OXIDIZING MATERIALS. USE WITH ADEQUATE
VENTILATION.
Other Precautions:AVOID CONTACT WITH EYES, SKIN, AND CLOTHING. THE
ROUTINE USE OF A NONALKALINE (ACID) TYPE OF HAND CLEANER AND
MINIMIZE POSSIBILITY OF SKIN REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (10 AIR CHANGES PER HOUR) SHOULD
BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS.
Other Protective Equipment:PROVIDE EYE WASH STATION, SAFETY SHOWER,
WASHING FACILITIES.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
THIS ENTRY IS FOR A CONCENTRATE SOLUTION FOR MAKING ONE GALLON OF
WORKING SOLUTION. SEE NSN 6750-00-F03-5708 P/N IND W FOR THE
WORKING SOLUTION DATA.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.362
pH:11.6.
Solubility in Water:COMPLETE
Appearance and Odor:TAN SOLUTION. ODORLESS.
Percent Volatiles by Volume:50-55
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF SULFUR.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO LOCAL, STATE AND FEDERAL REGULATIONS. IF PERMITTED, FLUSH TO
SEWER WITH LARGE AMOUNTS OF WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DESICCANT,ACTIVATED
Preparer's Name:CHARLES A. EISENHARD
CAGE:00334
CAGE:60777
CAGE:00334
============= Composition/Information on Ingredients =============
Ingred Name:DESICCANT,ACTIVATED
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
TRACT. ACUTE- IRRITATION OF EYES, NOSE AND THROAT BY DUST. MAY
CAUSE SKIN IRRITATION OR BURN IF WET. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION OF EYES, SKIN, NOSE AND THROAT BY
DUST
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER.
ORAL:GET MEDIC AL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:AS WITH ANY FIRE, WEAR PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS TO AVOID
INHALATION OF HAZARDOUS DECOMPOSTION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AND PLACE IN A DISPOSAL CONTAINER.
FLUSH AREA WITH WATER. AVOID RAISING DUST. VENTILATE AREA.
Neutralizing Agent:NOT RELEVENT
======================Handling and Storage ======================
Handling and Storage Precautions:OPEN CONTAINER SLOWLY TO AVOID DUST.
DO NOT GET IN EYES. AVOID BREATHING DUST & PROLONGED CONTACT WITH
SKIN. KEEP CONTAINER CLOSED. DO NOT INGEST.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. KEEP OUT OF REACH OF
CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH-APPROVED DUST RESPIRATOR IN DUSTY
SITUATIONS.
Ventilation:ADEQUATE
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T6
NRC/State Lic Num:NOT RELEVENT
Evaporation Rate & Reference:NOT RELEVENT
Appearance and Odor:ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SUDDEN CONTACT WITH HIGH CONCENTRATIONS OF CHEMICALS HAVING HIGH HEATS
OF ADSORPTION SUCH AS OLEFINS, HCL, ETC.
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:BURY IN LANDFILL. OBSERVE ALL LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WELDING WIRE AND METALLIZING WIRE, ALLOY 206-0
CAGE:DO018
CAGE:DO018
CAGE:0CMY0
============= Composition/Information on Ingredients =============
Ingred Name:IRON (FE)
CAS:7439-89-6
RTECS #:NO4565500
= Wt:.15
OSHA PEL:10 MG/M3 OXIDE FUME
ACGIH TLV:5 MG/M3 OXIDE FUME
Ingred Name:COPPER (CU)
CAS:7440-50-8
RTECS #:GL5325000
Minumum % Wt:4.2
Maxumum % Wt:5.
OSHA PEL:1 MG/M3, 0.2 MG/M3 F
ACGIH TLV:1 MG/M3, 0.1 MG/M3 F
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SILICON (SI). (MANUFACTURER PROVIDED INCORRECT CAS NUMBER:
7440-02-0)
CAS:7440-21-3
RTECS #:VW0400000
= Wt:.1
OSHA PEL:15 MG/M3,5 MG/M3 RES
ACGIH TLV:10 MG/M3
Ingred Name:ZINC (ZN)
CAS:7440-66-6
RTECS #:ZG8600000
= Wt:.1
OSHA PEL:15 MG/M3 T,5 MG/M3 R
ACGIH TLV:5 MG/M3 F,10 MG/M3 D
ACGIH STEL:10 MG/M3 FUME
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:OTHERS (MAXIMUM 0.05% EACH OF: LEAD (CAS 7439-92-1),
GALLIUM (CAS 7440-55-3), VANADIUM (CAS 7440-62-2) AND ZIRCONIUM
(CAS 7440-67-7). BERYLLIUM (CAS NO. 7440-41-7) SHALL NOT EXCEED
0.0008 %)
= Wt:.15
OSHA PEL:OTHER INFO
OSHA STEL:OTHER INFO
ACGIH TLV:OTHER INFO
ACGIH STEL:OTHER INFO
Ingred Name:ALUMINIUM (AL)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: REMAINDER
OSHA PEL:15 MG/M3 T,5 MG/M3 R
ACGIH TLV:10 MG/M3 DUST
Ingred Name:MANGANESE (MN)
CAS:7439-96-5
RTECS #:OO9275000
Minumum % Wt:.2
Maxumum % Wt:.5
OSHA PEL:5 MG/M3 CEILING FUME
ACGIH TLV:1 MG/M3 FUME
ACGIH STEL:3 MG/M3 FUME
Ingred Name:MAGNESIUM (MG)
CAS:7439-95-4
RTECS #:OM2100000
Minumum % Wt:.15
Maxumum % Wt:.35
OSHA PEL:15 MG/M3 TOTAL PART
ACGIH TLV:10 MG/M3 OXIDE FUME
Ingred Name:TITANIUM (TI)
CAS:7440-32-6
RTECS #:XR1700000
Minumum % Wt:.15
Maxumum % Wt:.3
OSHA PEL:15 MG/M3 TOTAL DUST
ACGIH TLV:10 MG/M3
Ingred Name:NICKEL (NI)
CAS:7440-02-0
RTECS #:QR5950000
= Wt:.05
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
= Wt:.05
===================== Hazards Identification =====================
LD50 LC50 Mixture:3160 MG/KG BODY WEIGHT, ORAL RAT.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EMERGENCY OVERVIEW: DUST OR FUME FROM
PROCESSING AMY CAUSE EYE, SKIN, OR UPPER RESPIRATORY IRRITATION OR
METAL FUME FEVER.POTENTIAL HEALTH EFFECTS: EYES: FUME CAN CAUSE
IRRITATION. ULTRAVIOLET RADI ATION FROM WELDING CAN CAUSE FLASH
BURNS. SKIN: CAN CAUSE IRRITATION. ULTRAVIOLET RADIATION FROM
WELDING CAN CAUSE FLASH BURNS. INHALATION: CAN CAUSE IRRITATION, ,
METAL FUME FEVER, ETC. CANCER HAZARD (SEE BELOW FOR TARGET ORGAN
EFFECTS RELATED TO SPECIFIC CHEMICALS.) ALUMINUM IS WELDED IN A
PROTECTIVE, INERT ATMOSPHERE SUCH AS ARGON OR HELIUM USING THE MIG
OR TIG PROCESS. WELDING PROCESSES GENE RATE (SIGNS & SYMPYOMS OF
OVEREXPOSURE)
Explanation of Carcinogenicity:LEAD AND LEAD COMPOUNDS: IARC GROUP 2B,
SUPPLEMENT 7, P. 230, 1987. NICKEL AND NICKEL COMPOUNDS: IARC
GROUP 1, VOL. 49, P. 257, 1990. NTP REASONABLY ANTICIPATED
CARCINOGEN, NINTH REPORT ON CARCINOGE NS. CHROMIUM AND CHROMIUM
COMPOUNDS: IARC GROUP 1, VOL 49, P. 49, 1990. NTP KNOWN
CARCINOGEN, NINTH REPORT ON CARCINOGENS.
Effects of Overexposure:HEALTH HAZARDS (CONT): WELDING FUMES AND AN
INTENSE ULTRAVIOLET RADIATION WHICH RESULTS IN THE FORMATION OF
OZONE AND OXIDES OF NITROGEN. ULTRAVIOLET RADIATION FROM WELDING
CAN ALSO CAUSE FLASH BURNSTO THE EYES AND SKIN. WELDING FUMES ARE
CARCINOGENIC AND ARE LISTED AS AN IARC GROUP 2B. EXPOSURE TO LOW
LEVELS OF OZONE CAN CAUSE IRRITATION OF THE EYES, NOSE AND THROAT.
INHALATION CAN CAUSE CHES T TIGHTNESS, HEADACHE, SHORTNESS OF
BREATH, COUGH, WHEEZE, NAUSEA, AND NARROWING OF AIRWAYS. SYMPTOMS
DISAPPEAR WHEN REMOVED FROM EXPOSURE. EXPOS TO HIGH LEVELS OF
OZONE MAY CAUSE ACUTE RESPIRATORY DISTRESS WITH (TOXICOLOGICAL
INFO)
Medical Cond Aggravated by Exposure:ASTHMA, CHRONIC LUNG DISEASE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYES WITH PLENTY OF WATER OR SALINE FOR AT LEAST
15 MINUTES. CONSULT A PHYSICIAN. SKIN: WASH THOROUGHLY WITH SOAP
AND WATER. CONSULT A PHYSICIAN IF IRRITATION PERSISTS. INHALATION:
REMOVE TO FRESH AIR. CHECK FOR CLEAR AIRWAY, BREATHING, AND
PRESENCE OF PULSE. PROVIDE CPR FOR PERSONS WITHOUT PULSE OR
RESPIRATIONS. CONSULT A PHYSICIAN. CONTAINS LEAD WHICH IS
LISTED AS A NAVY OCCUP ATIONAL CHEMICAL REPRODUCTIVE HAZARD. SEEK
CONSULTATION FROM APPROPRIATE HEALTH PROFESSIONAL CONCERNING LATEST
HEALTH HAZARD AND EXPOSURE INFORMATION .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE CLASS D EXTINGUISHING AGENTS OR DRY SAND ON
SMALL CHIPS OR FIRES. USE COARSE WATER SPRAY ON CHIPS, TURNINGS,
ETC. DO NOT USE HALOGENATED EXTING AGENTS ON SMALL CHIPS OR FINES.
Fire Fighting Procedures:PREPLANNED PROCEDURES SHOULD INCLUDE THE
ISOLATION OF THE BURNING MATERIAL AWAY FROM OTHER COMBUSTIBLES TO
ALLOW THE MATERIAL INVOLVED TO BURN ITSELF OUT, OR ALLOW EFFECTIVE
USE OF THE CLASS D EXTINGU ISHING AGENT. FIRE FIGHTERS SHOULD WEAR
NIOSH APPROVED, POSITIVE PRESSURE, SELFCONTAINED (UNUSUAL FIRE &
EXPLOS HAZARD)
Unusual Fire/Explosion Hazard:SMALL CHIPS, FINE TURNINGS, AND DUST MAY
IGNITE READILY. DUST CLOUDS MAY BE EXPLOSIVE; PREVENT FORMATION OF
A DUST CLOUD DURING PROCESSING. FLAMMABLE PROPERTIES:
NON-FLAMMABLE. FIREFIGHTI NG PROCEDURES (CONT):
BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING WHEN APPROPRIATE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL / LARGE SPILL: NO SPECIAL PROCEDURES.
OTHER PRECAUTIONS (CONT): CHARGES DURING HANDLING AND
TRANSFER OPERATIONS. MOLTEN ALUMINUM IN CONTACT WITH WATER CAN
CAUSE EXPLOSIONS. THE RISK IS GREATEST WHEN THERE IS SUFFICIENT
MOLTEN METAL TO ENTRAP OR SEAL OFF WATER. IF CONFINED, EVEN A FEW
DROPS OF WATER CAN LEAD TO VIOLENT EXPLOSIONS. DROPS OF MOLTEN
ALUMIUM IN WATER, WHILE (OTHER INFO)
======================Handling and Storage ======================
Handling and Storage Precautions:IF PROCESSING OF THESE PRODUCTS
INCLUDES POLISHING OR GRINDING OPERATIONS WHERE DUST OR EXTREMELY
FINE PARTICULATE IS GENERATED, OBTAIN AND FOLLOW SAFETY PROCEDURES
AND EQUIPMENT GUIDES CONTAINED IN ALUMINUM ASSOCIATION BULLETIN
F-1 AND NFPA BROCHURES (65, 651, 70 AND 77). USE (OTHER
PRECAUTIONS)
Other Precautions:HANDLING & STORAGE PRECAUTIONS (CONT): WITH ADEQUATE
EXPLOSION-PROOF VENTILATION TO MEET EXPOSURE LIMITS LISTED IN
(INGREDIENTS) SECTION. USE NON-SPARKING HANDLING EQUIPMENT. COVER
ANDRESEAL PARTIALLY EMPTY CONTAINERS. PROVIDE GROUNDING AND
BONDING WHERE NECESSARY TO PREVENT ACCUMULATION OF STATIC ( SPILL
PROCEDURES)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED DUST, FUME, OR OTHER
(ORGAINIC VAPOR) RESPPIRTOR AS APPROPRIATE. WHEN USING ALLOY
A357.0: THE PRESENCE OF AIRBORNE BERYLLIUM HAS BEEN DETECTED DURING
THE WELDING OF ALUMINUM ALLOYS WITH BERYLLIUM CONTENT AS LOW AS
0.002% BY WEIGHT. THE POTENTIAL FOR EXCEEDING BERYLLIUM STANDARDS
IS POSSIBLE WHEN MELTING, (WORK HYGENIC PRACTICES)
Ventilation:USE WITH ADEQUATE VENTILATION TO MEET EXPOSURE LIMITS
LISTED IN (INGREDIENTS) SECTION.
PROTECTIVE EQUIP)
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
HELMET, FACE SHIELD, FILTER LENS, ETC.) TO PREVENT EYE IRRITATION
OR FLASH BURNS.
Work Hygienic Practices:N/P. RESPIRATORY PROTECTION (CONT):
WELDING, ARC CUTTING, OR GRINDING OF THESE ALLOYS. SELECT THE
APPROPRIATE RESPIRATORY PROTECTION BASED ON THE ACTUAL OR POTENTIAL
AIRBORNE CONTAMINANTS.
Supplemental Safety and Health
INGREDIENTS (CONT): ALLOY INGREDIENTS: (% BY WEIGHT SHOWN AS A MAXIMUM
OR A RANGE, EXCEPT FOR ALUMINUM, WHICH IS MINIMUM & BY WEIGHT).
PHYSICAL/CHEMICAL PROPERTIES (CONT): DENSITY: APPROX .1 LB /IN3.
ODOR THRESHOLD (PPM): NOT APPLICABLE. COEFFICIENT OF WATER/OIL
DISTRIBUTION: NOT APPLICABLE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NOT APPLICABLE.
Melt/Freeze Pt:M.P/F.P Text:970-1215 F, 521-657 C
Vapor Pres:NO APPLICABLE.
Vapor Density:NOT APPLIC
Spec Gravity:NOT DETERMINED.
pH:NOT APPLICABLE.
Solubility in Water:NONE
Appearance and Odor:SOLID, SILVERY, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MOLTEN ALUMINUM CAN REACT VIOLENTLY WITH WATER, RUST, CERTAIN METAL
OXIDES (OXIDES OF COPPER, IRON, AND LEAD), AND NITRATES (AMMONIUM
NITRATE AND FERTILIZERS CONTAINING NITRATE).
Stability Condition to Avoid:STABLE UNDER NORMAL COND'S OF USE,
STORAGE, & TRANSPORTATION. HAZARDOUS DECOMP PRODS (CONT): OPON
TEMP. W/ STRONG OXIDIZERS: VIOLENT REACTION W/ MUCH HEAT.(COND TO
AVOID POLYMER)
Hazardous Decomposition Products:FOR FINELY DIVIDED ALUMINUM (EG SMALL
CHIPS, FINES): W/ WATER: SLOWLY GENERATES HYDROGEN & HEAT.
WATER/ALUMINUM MIXTURES MAY BE HAZARDOUS WHEN CONFINED. W/ HEAT:
OXDES AT RATE DEPENDENT (STABILITY COND)
=================== Toxicological Information===================
Toxicological Information:LD50 OR LC50 FOUND FOR ORAL, DERMAL OR
INHALATION ROUTES OF ADMINISTRATION: NICKEL: ORAL RAT LD50: 9000
MG/KG BODY WT. SILICON: ORAL RAT LD50: 3160 MG/KG BODY WT.
MANGANESE: ORAL RAT LD50: 9000 MG/KG BODY WT. SIGNS &
SYMPTOMS OF OVEREXPOSURE (CONT): SHORTNESS OF BREATH, PULMONARY
CHANGES, HEMORRHAGE AND PULMONARY EDEMA (FLUID IN THE LUNGS).
SYMPTOMS OF PULMONARY EDEMA MAY BE DELAYED FOR ONE OR MORE HOURS.
EXPOSURE OF TEST ANIMALS AND HUMAN TISSUE TO HIGH CONCENTRATIONS
HAS SHOWN CHROMOSOMAL CHANGES, REPRODUCTIVE EFFECTS, BLOOD CHANGES,
AND DEATH FROM LUNG CONGESTION. (ECOLOGICAL INFO )
===================== Ecological Information =====================
Ecological:ECOTOXICOLOGICAL / CHEMICAL FATE INFORMATION: NOT AVAILABLE.
TOXICOLOGICAL INFO (CONT): NITRIC OXIDE IS A SEVERE EYE,
SKIN, AND MUCOUS MEMBRANE IRRITANT; IT CAN CAUSE FORMATION OF
METHEMOGLOBIN (BLOOD DISORDER, AND SUBSEQUENT ACTION ON THE
CENTRAL NERVOUS STSTEM. NITROGEN MONOXIDE CAN BE FATAL IF INHALED
AT VERY HIGH CONCENTRATIONS (>100 PPM). ALUMINUM DUST / FINES AND
FUMES ARE A LOW HEA LTH RISK BY INHALATION. FOR STANDARD OPERATIONS
(MILLING, CUTTING, GRINDING), ALUMINUM DUST SHOULD BE TREATED AS
NUISANCE DUST AS DEFINED BY ACGIH. OVEREXPOSURE TO MAGNESIUM
OXIDE FUMES CAN CAUSE UP PER RESPIRATORY TRACT (TRANSPORT INFO)
==================== Disposal Considerations ====================
Waste Disposal Methods:COLLECT SCRAP FOR REMELTING. RCRA STATUS:
CHARATERIZE IN ACCORDANCE WITH 40 CFR 261 OR STATE EQUIVALENT.
DISPOSE IN ACCORDANCE WITH APPLICABLE FEDERAL, STATE, AND LOCAL
REGULATIONS .
=================== MSDS Transport Information ===================
Transport Information:U.S.A. DOT: NOT REGULATED. CANADIAN TDG HAZ
CLASS & PIN: NOT REGULATED. ECOLOGICAL INFO (CONT):
IRRITATION AND METAL FUME FEVER. TEMPORARY SYMPTOMS CAN INCLUDE
FEVER, CHILLS, NAUSEA, VOMITIN G AND MUSCULAR PAIN. EXPOSURE TO
MAGNESIUM METAL OR OXIDE DUST IS A LOW HEALTH RISK BY INHALATION.
OVEREXPOSURE TO MANGANESE OXIDE FUMES CAN CAUSE UPPER RESPIRATORY
TRACT IRRITATION AND METAL FUME FEVER. CHRONIC OVEREXPOS TO
MANGANESE DUST OR FUMES CAN CAUSE NERVOUS SYSTEM DISORDERS
(MANGANISM), MAY BE ASSOCIATED WITH PNEUMONITIS (INFLAMMATION OF
LUNG TISSUE), AND FIBROSIS (SCARRING) OF LUNG TI SS. CHRONIC
EXPOSURE TO (SARA III)
===================== Regulatory Information =====================
SARA Title III Information:SECTION 311/312 HAZARD CATEGORIES: IMMEDIATE
(ACUTE), DELAYED (CHRONIC). SECTION 313 TOXIC CHEMICALS: ALUMINUM
(FUME/DUST), BERYLLIUM, CHROMIUM, COPPER, LEAD, MANGANESE, NICKEL,
VANADIUM (FUME/DUST) AND ZINC. TRANSPORT INFO (CONT): INERT
DUSTS OF SILICON MAY CAUSE INCREASED AIRWAYS RESISTANCE AND
CONTRIBUTE TO CHRONIC BRONCHITIS. INTRATRACHEAL ADMINISTRATION OF
SILICON IN RABBITS PRODUCED S IGNIFICANT PULMONARY LESIONS.
EXPOSURE TO ZINC OXIDE FUMES SUBSEQUENT TO BURNING, WELDING AND
MOLTEN METAL WORK CAN RESULT IN "ZINC CHILLS" (METAL FUME FEVER)
AND UPPER RESPIRATORY TRACT IRRITATION. TEMPORARY SYMPTOMS
(FEDERAL REGULATORY)
Federal Regulatory Information:U.S. FED REGS: TSCA STATUS: ALL
COMPONENTS LISTED. CERCLA HAZARDOUS SUBSTANCES: BERYLLIUM,
CHROMIUM, COPPER, LEAD, MANGANESE, NICKEL, ZINC. SARA III
(CONT): CAN INCLUDEFEVER, CHILLS, NAUSEA, VOM ITING, AND MUSCULAR
PAIN. EXPOSURE TO DUST OR FINES PRESENTS A LOW HEALTH RISK BY
INHALATION. HEXAVALENT CHROMIUM (CHROME VI) CAN CAUSE PULMONARY
EDEMA, ASTHMA, KIDNEY DAMAGE, PRIMARY IRRITANT DERMATI TIS,
SENSITIZATION DERMATITIS, AND SKIN ULCERATION. HEXAVALENT CHROMIUM
IS LISTED AS AN IARC GROUP 1 CARCINOGEN. CHRONIC INHAL OR
OVEREXPOS HAS BEEN ASSOC W/LUNG, NASAL, & GI CANCER. CHROMIUM &
SOME OF ITS COMPONENTS ARE LISTED (STATE REGS)
State Regulatory Information:PA: "SPECIAL HAZARDOUS SUBSTANCE":
BERYLLIUM, CHROMIUM, & NICKEL. CA PROP 65: BERYLLIUM, HEXAVALENT
CHROMIUM & NICKEL. LEAD IS KNOWN TO THE STATE OF CA TO CAUSE BIRTH
DEFECTS AND OTHER REPRODUCTIVE HA RM. FEDERAL REGS (CONT): AS
CARCINOGENIC BY NTP. HEXAVALENT CHROMIUM COMPOUNDS MAY BE GENERATED
DURING WELDING OPERATIONS WITH ALLOYS CONTAINING CHROMIUM. THE
POTENTIAL FOR OVEREXPOSURE TO COPPER FUME MAY EXIST WHEN WELDING,
FLAME CUTTING, ETC. EXPOSURE TO NICKEL DUST & FUME & EXCESS LEVELS
OFBERYLLIUM IS POSSIBLE. CONTACT NAVY ENVIRONMENTAL HEALTH
CENTER FOR ADDITIONAL INFORMATION .
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HM 1410 ULTRA BRITE WHITE AMERICA'S FINEST (OTHER INFO)
Resp. Party Other MSDS Num.:S3
CAGE:01PD6
CAGE:EC0MP
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:1,2-ETHANEDIOL: (ETHYLENE GLYCOL)
CAS:107-21-1
RTECS #:KW2975000
Minumum % Wt:1.
Maxumum % Wt:5.
ACGIH STEL:C127 MG/M3;C50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:KAOLIN: (CLAY)
CAS:1332-58-7
RTECS #:GF1670500
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:15 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:PROPANOIC ACID, 2-METHYL-, MONOESTER WITH
2,2,4-TRIMETHYL-1,3-PENTANEDIOL: (TEXANOL)
CAS:25265-77-4
RTECS #:UF6000000
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:SILICA GEL, PRECIPITATED., CRYSTALLINE.-FREE: (SILICA GEL,
AMORPHOUS)
CAS:112926-00-8
RTECS #:VV7315000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:10 MG/M3
Ingred Name:TITANIUM OXIDE: (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Minumum % Wt:10.
Maxumum % Wt:20.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:2-PROPENOIC ACID, BUTYL ESTER, POLYMER WITH ETHENYL
ACETATE: (BUTYL ACYLATE - VINYL ACETATE POLYMER)
CAS:25067-01-0
Minumum % Wt:10.
Maxumum % Wt:20.
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:10.
Maxumum % Wt:40.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: IRRIT OF RESP TRACT, LUNGS.
PRLNG INHAL MAY LEAD TO MUC MEMB IRRIT, DROW, DIZZ
&/LIGHTHEADEDNESS, HDCH, NAUSEA, VOMIT, GI DISTURB, COUGHING,
APATHY, CNS DEPRESSION, ANESTHETIC EFFECT/NARCOSIS, BLOOD
ABNORMALITIES, KIDNEY DMG, LOSS OF CONSCIOUSNESS. SKIN: IRRIT OF
SKIN. PRLNG/RPTD CONTACT CAN CAUSE DERM, DEFATTING. SKIN CONTACT
MAY RESULT IN DERMAL ABSORPTION OF COMPONENT(S) OF THIS PROD WHI CH
MAY CAUSE APATHY. EYE: IRRIT OF EYES. PRLNG/RPTD CONTACT CAN CAUSE
CONJ. INGEST: MAY CAUSE FATIGUE, DROW, DIZZ &/LIGHTHEADEDNESS,
HDCH, NAUSEA, VOMIT, DIARR, GI DISTURB, SEVERE ABDOM PAIN, APATHY,
CNS DEPRESSION, RESP (EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ: PROBLEMS, INTOXICATION, CNS DMG,
LIVER DMG, KIDNEY DMG, BLADDER DMG, PULM EDEMA, LOSS OF
CONSCIOUSNESS, CYANOSIS, ACUTE POISONING, RESP FAILURE, CARDIAC
FAILURE, BRAIN DMG, DEATH. SUPPLEMENT AL HEALTH INFO: CNTNS CHEM
THAT IS MOD TOX BY INGEST. OTHER EFTS OF OVEREXP MAY INCLUDE TOX TO
LIVER, KIDNEY. MAY BE ABSORBED THRU SKIN. SOME LAB TEST RSLTS HAVE
SHOWN ETHYLENE GLYCOL TO BE AN ANIMAL TERATOGEN. A STUDY CONDUCTED
BY NTP, USING A CONTINUOUS BREEDING PROTOCOL, DEMONSTRATED THAT
DIETHYLENE GLYCOL IN DRINKING H*2O AT CONC OF 3.5% (6.1 G/KG/DAY)
RSLTD IN DECRD FERTILITY & REPROD PERFORM ANCE IN MICE. (SUPDAT)
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS
KIDNEY DISORDERS LIVER DISORDERS NERVOUS SYSTEM DISORDERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. GET EMERGENCY MEDICAL ATTENTION. HAVE TRAINED PERSON
GIVE OXYGEN IF NECESSARY. GET MEDICAL HELP FOR ANY BREATHING
DIFFICULTY. REMOVETO FRESH AIR IF INHALATION CAUSES EYE WATERING,
HEADACHES, DIZZINESS/OTHER DISCOMFORT. SKIN: FLUSH FROM SKIN WITH
WATER. THEN WASH THOROUGLY WITH SOAP & WATER. REMOVE CONTAMINATED
CLOTHING. WASH CONTA MINATED CLOTHING BEFORE RE-USE. EYE: FLUSH
IMMEDIATELY W/LARGE AMOUNTS OF WATER, ESPECIALLY UNDER LIDS FOR AT
LEAST 15 MINUTES. IF IRRITATION/OTHER EFFECTS PERSIST, OBTAIN
MEDICAL TREATMENT. INGESTION : OBTAIN MEDICAL TREATMENT
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL OR FOAM, WATER FOG, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CNTNRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT/FIRE. VAPS ARE HEAVIER THAN AIR & MAY TRAVEL LONG
DISTANCES TO SOURCE OF IGNIT & FLASH BACK. VAPS CAN FORM EXPLOS
MIXT IN AIR AT ELEVATED TEMP. C LOSED CNTNRS MAY BURST IF EXPOSED
TO EXTREME HEAT/FIRE. IN CLOSED TANKS, H*2O/FOAM MAY CAUSE
FROTHING/ERUPTION.
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY W/APPLIC HEALTH & ENVIRON REGS.
ELIMINATE ALL SOURCES OF IGNIT. VENT AREA. SPILLS MAY BE COLLECTED
W/ABSORB MATLS. EVACUATE ALL UNNEC PERS. PLACE COLLECTED MATERIAL
IN PROPER CNTNR. LRG SPILLS- SHUT OFF LEAK IF SAFE TO DO SO. DIKE &
CNTN SPILL. PUMP TO STORAGE/SALVAGE VESSELS. USE ABSORB TO PICK UP
EXCESS RESIDUE. KEEP SALVAGEABLE MATL & RINSE H*2O OUT OF SEWERS &
H*2O COURSES. (OTHER INFO)
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 100F. KEEP AWAY FROM HEAT,
SPARKS AND OPEN FLAME. KEEP FROM FREEZING. USE ONLY WITH ADEQUATE
VENTILATION. DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
AVOID CONTACT WITH SKIN AND EYES, AND BREATHING OF VAPORS.
Other Precautions:KEEP CONTAINERS TIGHTLY CLOSED AND UPRIGHT WHEN NOT
IN USE. AVOID CONDITIONS WHICH RESULT IN FORMATION OF INHALABLE
PARTICLES SUCH AS SPRAYING OR ABRADING (SANDING) PAINTED SURFACES.
IF SUCH CONDITION S CANNOT BE AVOIDED, USE APPROPRIATE RESPIRATORY
PROTECTION AS DIRECTED UNDER SPECIAL PROTECTION INF ORMATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
ONLY NIOSH APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29
CFR 1910.134
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . IMPERVIOUS CLOTHING AND APRON.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING,
ESPECIALLY BEFORE EATING OR SMOKING.
Supplemental Safety and Health
EFT OF OVEREXP: THESE EFTS WERE NOT SEEN IN LOWER DOSE LEVELS
EVALUATED. SINCE EXPOS FROM INCIDENTAL CNTCT IS LIKELY TO BE LOWER
BY SEVERAL DEGREES OF MAGNITUDE & ROUTE OF EXPOS USED IN STUDY
DOESN'T REFLECT A LIKELY ROUTE FROM OCCUP/CONSUMER USE.
SIGNIFICANCE OF FINDING TO HUMAN IS UNCERTAIN.
================== Physical/Chemical Properties ==================
Boiling Pt:=100.C, 212.F
B.P. Text:212F - 477F
VOC Pounds/Gallon:183
Appearance and Odor:ULTRA BRIGHT WHITE
Percent Volatiles by Volume:67.53
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, REDUCING AGENTS, BASES, ALUMINUM, ZINC, HYDROGEN
CHLORIDE, METALS, NITRIC ACID, HYDROFLUORIC ACID, VINYL POLYMERS,
METAL COMPOUNDS, HYDROGEN FLUORIDE, MAGNESIUM, SODIUM, POTASSIUM.
Stability Condition to Avoid:ELEVATED TEMPERATURES, CONTACT WITH
OXIDIZING AGENT, CONTACT WITH ALUMINUM OR ZINC, FREEZING, SPARKS,
OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXYGEN, TOXIC GASES. PROPIONALDEHYDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. AVOID DISCHARGE TO NATURAL
WATERS.
=================== MSDS Transport Information ===================
Transport Information:DOT, PROPER SHIPPING NAME: PAINT. **PROTECT FROM
FREEZING**
===================== Regulatory Information =====================
SARA Title III Information:SARA SECTION 313 CHEMICAL: 1,2-ETHANEDIOL.
Federal Regulatory Information:CERCLA CHEMICAL: 1,2-ETHANEDIOL.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SC250 SINGLE CHANGE PAINT
CAGE:K9082
CAGE:K9082
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (PROPYLENE
GLYCOL METHYL ETHER (ING 2)
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 1:ACETATE) (PMA) VP:3.7 @ 20C. VAP DENS:4.55.
RTECS #:9999999ZZ
Ingred Name:XYLENE (SARA 313) (CERCLA) VP:10 @ 28C. VAP DENS:3.7.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 30%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PIGMENTS; (THERMALLY SENSITIVE PIGMENTS)
Fraction by Wt: 20%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9495
Ingred Name:ACRYLIC RESINS
CAS:901-88-2
Fraction by Wt: 20%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SOLVENT: IRRITATION TO EYES, THROAT,
NOSE AND LUNGS. MAY LEAD TO HEADACHE, DROWSINESS, NAUSEA AND
POSSIBLE NARCOSIS. COULD LEAD TO KIDNEY DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE PATIENT FROM FUMES TO FRESH AIR.
INGESTION: SEEK IMMEDIATE MEDICAL ATTENTION. IF CONSCIOUS GIVE MILK
OR MILK AND ACTIVATED CHARCOAL. EYE: IRRIGATE WITH WATER FOR AT
LEAST 15 MINUTES . SEEK MEDICAL ATTENTION IF IRRITATION PERSISTS.
SKIN: WASH OFF WITH SOAP AND WATER. IF IRRITATION PERSISTS SEEK
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:40.0F,4.4C
Extinguishing Media:CO*2, DRY POWDER, ALOCOHOL RESISTANT FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP WITH SAND, EARTH, RAGS, SAWDUST. FLUSH
SURFACE DOWN AFTER WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN APPROVED WELL VENTILATED
PAINT STORE. AVOID HEAT. AVOID INHALATION OF VAPORS. USE IN WELL
VENTILATED AREAS. AVOID SKIN/EYE CONTACT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED CHEMICAL CARTRIDGE TYPE
SPECIFICALLY FOR SOLVENTS.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . OVERALLS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SOLUBILITY IN WATER: SOLVENTS PARTIALLY SOLUBLE, PIGMENTS PARTIALLY
SOLUBLE, RESIN INSOLUBLE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:284F,140C
Vapor Pres:SEE ING
Vapor Density:SEE ING
Spec Gravity:1.1 (H*2O = 1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SUPDATA
Appearance and Odor:BLUE PAINT. SWEET SMELL.
Percent Volatiles by Volume:50
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HEAT, NAKED LIGHTS. PAINT IS FLAMMABLE.
Hazardous Decomposition Products:ON HEATING, CYANINE, AMMONIA, CARBON
MONOXIDE ARE EVOLVED-AVOID INHALATION. APPLIES TO DRY PAINT FILM
ALSO.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DELESTROGEN, 20 MG/ML
CAGE:GO233
CAGE:GO233
CAGE:4T649
============= Composition/Information on Ingredients =============
Ingred Name:ESTRADIOL VALERATE; DELESTROGEN
CAS:979-32-8
RTECS #:KG5793000
Fraction by Wt: 2%
Ingred Name:CASTOR OIL
CAS:8001-79-4
RTECS #:FI4100000
Fraction by Wt: >1%
Ingred Name:BENZYL BENZOATE
CAS:120-51-4
Fraction by Wt: >1%
Ingred Name:BENZYL ALCOHOL
CAS:100-51-6
RTECS #:DN3150000
Fraction by Wt: >1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHRONIC EXPOSURE TO HIGH THERAPEUTIC
DOSES OF ESTROGENS HAS BEEN ASSOCIATED W/AN INCREASED INCIDENCE OF
ENDOMETRIAL CANCER IN HUMANS. INGESTION/SKIN ABSORPTION MAY OCCUR.
CASTOR OIL: LAXATIVE EFFECTS. EYE IRRITANT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION/SKIN: NAUSEA, VOMITING, CHOLESTATIC
JAUNDICE, SKIN CHANGES, EDEMA, HEADACHES, DIZZINESS, DEPRESSION,
CORNEAL CHANGES. WOMEN MAY EXPERIENCE MENSTRUAL IRREGULARITIES &
BREAST TENDERNESS. CASTO R OIL: ABDOMINAL CRAMPS, DIARRHEA, NAUSEA
& VOMITING. ASPIRATION MAY RESULT IN LIPID PNEUMONIA.
Medical Cond Aggravated by Exposure:CANCER, CARDIAC DISEASE, RENAL
DISEASE, METABOLIC BONE DISEASE, GALLBLADDER DISEASE, ABNORMAL
BLOOD CLOTTING, HIGH BLOOD PRESSURE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15-20 MINS. SKIN: WASH
W/SOAP & WATER FOR 15-20 MINS. INGESTION: IF CONSCIOUS, WASH MOUTH
OUT W/WATER. DON'T INDUCE VOMITING. INHALATION: REMOVE TO FRESH
AIR. IF BREA THING IS DIFFICULT, ADMINISTER OXYGEN. IF BREATHING
STOPS, GIVE ARTIFICIAL RESPIRATION. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, CO2, OR FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING. USE WATER TO KEEP FIRE-EXPOSED CONTAINERS
COOL. FIGHT FROM MAXIMUM SAFE DISTANCE.
Unusual Fire/Explosion Hazard:DIVERT RUNOFF TO A SAFE AREA.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROTECTIVE CLOTHING. ABSORB
LIQUID ON APPROPRIATE ABSORBENT MATERIAL & PLACE INTO CONTAINER FOR
DISPOSAL. AREA SHOULD BE VENTILATED & DECONTAMINATED AFTER MATERIAL
HAS BEEN PICKED UP.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMP, PROTECTED FROM AIR
& LIGHT.
Other Precautions:PERSONS WHO ARE ALLERGIC TO THIS SUBSTANCE SHOULD
AVOID CONTACT W/THIS SUBSTANCE. PREGNANT WOMEN SHOULD AVOID
EXPOSURE TO ESTROGENS. ABSORPTION OF THERAPEUTIC DOSES OF ESTROGENS
MAY RESULT IN INTOLERA NCE TO CONTACT LENS.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:GOWN
Supplemental Safety and Health
THERAPEUTIC AGENTS ARE INTENDED FOR USE UNDER DIRECTION OF A PHYSICIAN
&/OR UNDER CONDITIONS OF USE DESCRIBED ON THE LABEL.
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS TO PALE YELLOW SOLUTION, FATTY ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AIR & LIGHT
Hazardous Decomposition Products:NOXIOUS PRODUCTS INCLUDING CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. IT IS RECOMMENDED THAT FORMULATION BE TREATED
AS A HAZARDOUS MATERIAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:14380 SODIUM HYDROXIDE SOLUTION, 3.636N
CAGE:4T252
CAGE:91224
CAGE:4T252
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: <15%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DEMINERALIZED WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: T0 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50 IS NOT KNOWN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS CORROSIVE TO ALL BODY
TISSUES. PRODUCT WOULD BE CORROSIVE TO RESPIRATORY TRACT IF INHALED
AS A MIST. MIST FORMATION IS SO UNLIKELY THAT IT IS NOT TREATED AS
A VIABLE EXPOSURE.
Explanation of Carcinogenicity:MFR STATES ON MSDS THAT ANY INGREDIENT
NOT LISTED BY NAME (I.E. "OTHER INGREDIENT") IS NOT LISTED AS A
CARCINOGEN.
Effects of Overexposure:EYES: BURNS,POSSIBLE SCARRING
SKIN:BURNS,INHALED:N/R SEE HEALTH HAZARD. INGESTED: G/I
IRRITATION,BURNS,POSSIBLE SCARRING.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE. INHALED:REMOVE TO FRESH AIR. INGESTED:DO NOT INDUCE
VOMITING. GIVE 2 GL ASSES OF MILK OR WATER AND GET IMMEDIATE
MEDICAL CARE. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. IF IRRITATION
PERSISTS OR IS SEVERE,SEE A DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NON FLAMMABLE
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER AS LIQUID IF POSSIBLE. ABSORB
REMAINDER ON CLOTH,PAPER,VERMICULITE. NEUTRALIZE LIQUID TO PH 6.0
TO 9.0 FOR DISPOSAL.
Neutralizing Agent:6M HYDROCHLORIC ACID
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. KEEP
CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. AVOID CONTACT WITH
EYES ,SKIN, CLOTHING. DO NOT BREATHE CHEMICALS. OBSERVE
INCOMPATIBILITIES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. ALWAYS USE NIOSH/MSHA APPROVED
RESPIRATORS WHEN REQUIRED.
Ventilation:NOT NORMALLY REQUIRED. USE LAB HOOD OR OTHER LOCAL EXHAUST
TO MAINTAIN EXPOSURE BELOW PEL/TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER. LAB COAT
OR APRON
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT.
Supplemental Safety and Health
USED IN KIT NSN 6830-01-154-1535. CHANGE NUMBER 7557.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F/100C
Spec Gravity:1.136
pH:14
Evaporation Rate & Reference:0.26 (WATER = 1)
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR COLORLESS LIQUID,NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:HEAT AND EVAPORATION
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL FEDERAL, STATE AND LOCAL
REGULATIONS. MANUFACTURER SUGGESTS THAT DISPOSAL MAY BE DONE BY
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3 M BRAND TYPE 885 IMAGING POWDER (OBSOLETE
CAGE:76381
CAGE:76381
============= Composition/Information on Ingredients =============
Ingred Name:MAGNETITE
CAS:1309-38-2
Fraction by Wt: 45 - 60%
Other REC Limits:NONE SPECIFIED
Ingred Name:BISPHENOL A PROPYLENE OXIDE FUMARATE/POLYESTER RESIN
CAS:39382-25-7
Fraction by Wt: 35 - 50%
Other REC Limits:NONE SPECIFIED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 1 - 3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:SILICA GEL/AMORPHOUS SILICA
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: < 0.1%
Other REC Limits:NONE SPECIFIED
Ingred Name:FLUOROSILICONE OIL/FLUOROSILICONE LIQUID
CAS:63148-56-1
Fraction by Wt: < 1.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:NOT ESTABLISHED.
ACGIH TLV:NOT ESTABLISHED.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYES:DUST MAY CAUSE SLIGHT
IRRITATION.SKIN:NON-IRRITATING.INHALATION:DUST MAY CAUSE SLIGHT
UPPER RESPIRATORY SYSTEM IRRITATION.INGESTION:NO ADVERSE HEALTH
EFFECTS ARE EXPECTED.CHRONIC-NONE KNOWN .
Effects of Overexposure:DUST MAY CAUSE SLIGHT EYE IRRITATION.
INHALATION OF DUST MAY CAUSE SLIGHT UPPER RESPIRATORY SYSTEM
IRRITATION.
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL CARE IF NEEDED.INHALATION:REMOVE TO FRESH
AIR.EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES
HOLDING EYELIDS OPEN.SKIN:WASH WITH SOAP AND WATER.INGESTION:SEE A
PHYSICIAN IF SYM PTOMS OCCUR.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:IN COPIER: CARBON DIOXIDE. IN WAREHOUSE : WATER,
CARBON DIOXIDE, FOAM
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:TONER DUST CAN BE EXPLOSIVE IF EXPOSED TO
FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:EXTINGUISH IGNITION SOURCES. COLLECT SPILLED
MATERIAL WITHOUT CAUSING AIRBORNE DUST. SPRAY SPILL WITH WATER IF
NECESSARY.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-NONE. AVOID PROLONGED
INHALATION OF EXCESSIVE DUST.
Other Precautions:AVOID RAISING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR CONDITIONS WHERE EXPOSURE TO DUST IS
APPARENT, A NIOSH APPROVED RESPIRATOR FOR DUST APPROPRIATE TO THE
CONCENTRATION MAY BE WORN.
Ventilation:NORMAL OFFICE CONDITIONS
Other Protective Equipment:EYE WASH STATION.
Work Hygienic Practices:AVOID BREATHING DUST IF SAMPLE IS SPILLED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:APPROX. 2
Solubility in Water:NIL
Appearance and Odor:FINE BLACK POWDER, NO ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, SHORT
CHAIN HYDROCARBONS AND CARBON PARTICULATES IF BURNED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE PRODUCT IN A SANITARY LANDFILL
OR INCINERATE IN A COMMERCIAL OR MUNICIPAL FACILITY.DISPOSAL SHOULD
BE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS
AND REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:TT-P-96D
CAGE:60141
CAGE:60141
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENTS
Fraction by Wt: 38%
Ingred Name:ACRYLIC EMULSION
Ingred Name:GLYCOL
===================== Hazards Identification =====================
Effects of Overexposure:HEADACHE
================== Accidental Release Measures ==================
Spill Release Procedures:WASH OFF WITH WATER
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE VENTILATION
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FREEZING
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WORLD CUP-CLASSIC ROSE,XYMEX 100
CAGE:58396
CAGE:58396
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- CONCENTRATION OF ODOR MAY LIMIT VOLUNTARY
EXPOSURE. MAY CAUSE MILD EYE IRRITATION. MAY CAUSE MILD SKIN
IRRITATION. THE EFFECTS OF INGESTION A RE UNKNOWN. CHRONIC-
UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MILD IRRITATION
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED: MOVE TO FRESH
AIR. PROVIDE OXYGEN IF NEEDED. EYES: FLUSH WITH PLENTY OF WATER.
HOLD EYELIDS OPEN. SEE PHYSICIAN. SKIN: WASH WITH SOAP & WATER.
ORAL: GET MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:200F,93C
Extinguishing Media:USE CARBON DIOXIDE, FOAM OR DRY CHEMICAL. USE WATER
SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL WITH INERT MATERIAL SUCH AS
VERMICULITE OR USE PUMP. PLACE IN A CONTAINER FOR DISPOSAL. CLEAN
AREA THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS AWAY FROM
EXCESSIVE HEAT AND STRONG OXIDIZING AGENTS. KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:AVOID CONTACT WITH EYES, SKIN AND CLOTHING. USE WITH
ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING. FOR
INDUSTRIAL USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATIONS, SEE PNI A OR B, SAME NSN.
================== Physical/Chemical Properties ==================
HCC:V5
NRC/State Lic Num:NOT RELEVANT
Vapor Pres:0.000
Vapor Density:>1
Spec Gravity:0.9436
Appearance and Odor:TRANSPARENT CLEAR LIQUID - FLORAL CHARACTERISTIC
ODOR OF BOUQUET OF ROSES
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEATING OVER 60C/140F
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL REGULATIONS. CONTRACT WITH A LICENSED
CHEMICAL DISPOSAL AGENCY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:6117
CAGE:JO776
CAGE:96341
CAGE:JO776
============= Composition/Information on Ingredients =============
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
================== Accidental Release Measures ==================
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:A2
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ILFOSPEED 2000 FIXER/REPLENISHER
CAGE:64145
CAGE:64145
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 40-45%
Ingred Name:SODIUM BISULFITE (SARA III)
CAS:7631-90-5
RTECS #:VZ2000000
Fraction by Wt: 1-3%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 40-45%
Ingred Name:SODIUM ACETATE
CAS:126-96-5
RTECS #:AJ4375000
Fraction by Wt: 3-6%
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: 2-5%
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 1-3%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT MAY CAUSE EYE, SKIN &
GASTROINTESTINAL TRACT IRRITATION. IT IS CONSIDERED A LOW
INHALATION HAZARD UNDER TYPICAL USE CONDITIONS.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO INGREDIENT
LISTED AS CARCINOGEN BY IARC, NTP, OR OSHA.
Effects of Overexposure:EYE, SKIN & GASTROINTESTINAL TRACT IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: IMMEDIATELY FLUSH WITH
RUNNING WATER FOR 15 MINUTES. GET MEDICAL ATTENTION. SKIN: WASH
THOROUGHLY WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. IF
IRRITATIO N DEVELOPS, GET MEDICAL ATTENTION. INGESTION: IF
CONSCIOUS, GIVE GLASS OF WATER TO DRINK AND INDUCE VOMITING. GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE MEDIA APPROPRIATE FOR SOURCE OF FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE WITH WATER AND FLUSH TO SEWER.
DISCHARGE, TREATMENT OR DISPOSAL MAY BE REGULATED BY FEDERAL, STATE
OR LOCAL LAWS.
Neutralizing Agent:WATER DILUTION
======================Handling and Storage ======================
Handling and Storage Precautions:TO USE PRODUCT SAFELY, READ LABELS AND
INSTRUCTIONS AND CARRY OUT APPROPRIATE PRECAUTIONS. STORE IN A COOL
DRY AREA AWAY FROM STRONG ACIDS OR ALKALIS.
Other Precautions:BEFORE USING THIS PRODUCT, READ MSDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR IF PEL/TLV IS EXCEEDED.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.280
pH:5.1
Evaporation Rate & Reference:SLOW
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS T0 LIGHT YELLOW LIQUID, VINEGAR
ODOR
Percent Volatiles by Volume:45
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS OR STRONG ALKALIS
Hazardous Decomposition Products:OXIDES OF NITROGEN, SULFUR OR AMMONIA
GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:REFRESH (ODOR COUNTERACTANT W/LEMON GRASS FRAGRANCE)
Preparer's Name:ATA DANESHRAD
CAGE:NO277
CAGE:0PWJ2
CAGE:NO277
============= Composition/Information on Ingredients =============
Ingred Name:BENZYLALKONIUM CHLORIDE (QUATERNARY AMMONIUM COMPOUND)
CAS:139-08-2
RTECS #:BO7150000
Fraction by Wt: 1-4%
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOC = 87.0 G/L
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT EST.
ACGIH TLV:NOT EST.
Ingred Name:ETHOCYLATED NONYL PHENOL (ALKYL PHENOL ETHOXYLATE)
CAS:9016-45-9
RTECS #:MD0900000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: POS MOD IRRIT. SKIN: POS
IRRIT/DRYING/DERMATITIS W/REPEATED/PROLONGED CONTACT. INHAL: POS
NASAL/RESP
IRRIT/DIZZINESS/WEAKNESS/FATIGUE/NAUSEA/HEADACHE/ANESTHETIC
EFFECTS. SENSITIVE PEOPLE MAY HAV E SYMPTOMS NORMALLY ASSOCIATED
W/CONCENTRATE. INGES: IMMED BURNING PAIN IN MOUTH/THROAT/ABDOMEN.
IRRIT/NAUSEA/VOMITING*
Explanation of Carcinogenicity:***BICARBONATE SODA/VINEGAR. IF
CONSCIOUS INDUCE VOMITING THEN GIVE FLUIDS AGAIN.
Effects of Overexposure:*DIARRHEA. SERIOUS HEALTH EFFECTS. INGESTION OF
4-12 OZ MAY POISON/KILL. SKELATAL MUSCLE PARALYSIS AFFECTING
ABILITY TO BREATHE, CIRCULATORY SHOCK, CONVULSIONS: MAY BE FATAL.
CHRONIC: SKIN: POS ALLERG IC REACTION/IRRIT/INFLAM. EYES:
STINGING/WATERING.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN/BLOOD DISORDERS,
RESP DISEASES. MAY ENHANCE ALLERGIC CONDITIONS. DR.'S NOTE:
PROBABLE MUCOSAL DAMAGE MAY CONTRAINDICATE USE OF GASTRIC LAVAGE.
MEASURES AGAINST CIRCULATORY SHOCK**
======================= First Aid Measures =======================
First Aid:EYES: LIFT LIDS,, FLUSH W/COOL WATER 15 MIN. DON'T RUB. GET
MED AID. DON'T NEUTRLZE W/CHEM AGENTS. SKIN:FLUSH W/WATER. REMOVE
CONTAM CLOTHES, WASH BEFORE REUSE. KEEP WARM. INHAL: GET FRESH AIR.
GIVE O 2IF REQ. IF IRRIT PERSISTS GET MED AID;BREATHING STOPS GET
IMMED MED AID.GIVE ARTIF RESP. INGEST: IMMED MED AID. WASH MOUTH.
DILUTE W/MOD AMTS MILK/WATER. AVOID ALCOHOL. DON'T GIVE FRUIT
JUICE***
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>75F,>24C
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:EVACUATE NONESSENTIAL PERSONNEL. FIREFIGHERS
SHOULD WEAR POSITIVE PRESSURE SCBA W/FULL FACEPIECE. HEATED SOLVENT
VAPORS CAN TRAVEL IGNIT SOURCES & FLASHBACK.
Unusual Fire/Explosion Hazard:USE WATER FOG/SPRAY TO COOL/LOWER
PRESSURE OF FIRE-EXPOSED CONTAINERS, TO FLUSH VAPORS AWAY, & TO
FLUSH/DILUTE SPILLED MAT'L. EXPLOSIVE MIXTURES CAN FORM W/AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:SM: MOP UP/RINSE AREA. PUT LIQ IN NONLEAKING
SHUT OFF LEAK IF SAFE. DIKE/CONTAIN. TRANSFER LIQ TO PLASTIC
DRUM/CNTNRS FOR RECOVERY/DI SPOSAL. RECLAIM IF POSSIBLE. RINSE/MOP
UP.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP COOL/DRY IN ORIG POLYETHYLENE
CNTNR/AWAY FROM OTHER CHEM/FOOD.MAY BE RESIDUE IN EMPTY
CNTNR.DISPOSE WMPTY CNTNRS IN ENVIRNMNT SAFE AREA.
Other Precautions:EMPTY CNTNR: HAZ IF MISUSE.CUTTING/WELDING RELEASES
RESIDUE.DON'T PRESSURIZE,EXPOSE TO HEAT/FLAME.KEEP CNTNR
CLSD.CAPS/SPOUTS/BUNGS IN PLACE.KEEP FROM
EYES/SKIN/CLOTHES/KIDS.DON'T TAKE INTERNALLY,MIX W/OTHER CHEM
BEFORE READING LABEL/MSDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR FOR MIST/SPRAYS.
Ventilation:ADEQUATE LOCAL EXHAUST IN CONFINED AREAS.
Other Protective Equipment:USE REASONABLE CLEANLINESS, WASHING EXPOSED
SKIN SEVERAL TIMES DAILY, ESPEC BEFORE MEALS. WASH SOILED WORK
CLOTHES DAILY
Work Hygienic Practices:KEEP FROM FOOD.DON'T EAT/DRINK/SMOKE ID
AFTER EACH USE.
Supplemental Safety and Health
DON'T MIX W/OTHER CHEMICALS OR CLEANING AGENTS UNTIL READING LABEL
INSTRUCTIONS & MSDS. **AS WELL AS OXYGEN/MEASURES TO SUPPORT
BREATHING MANUALLY/MECHANICALLY MAY BE NEEDED.IF PERSISTANT,
CONVULSIONS MAY BE CONTROLLED BY CAUTIOUS IV INJECTION OF
SHORT-ACTING BARBITURATE DRUG.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:<32F,<0C
Vapor Pres:<17 @ 68F
Spec Gravity:1.01
pH:6.5
Evaporation Rate & Reference:<1 (BUAC=1)
Solubility in Water:100%
Appearance and Odor:PINK SOLUTION, BUBBLE GUM ODOR
Percent Volatiles by Volume:91.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS/STRONG REDUCING AGENTS.
Stability Condition to Avoid:HEAT, TEMPERATURE EXTREMES.
Hazardous Decomposition Products:CARBON/NITROGEN OXIDES, HYDROGEN
CHLORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL CONTAMINATED ABSORBENT. DON'T LANDFILL
LIQ. MAY DISPOSE WELL-DILUTED SMALL AMTS IN SEWER. LG: KEEP OUT OF
SEWERS/OPEN BODIES WATER. COMPLY W/ALL APPLICABLE LAWS. DETERMINE
IF UNCONTROLLED REL EASE REPORTABLE UNDER APPLICABLE REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & SYNTHETIC RESIN & NICKEL ALLOY COMPOSTION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DDTC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NAPA NO.61 BRONZE ROD 84-480 (COPPER BASE ELECTRODE)
CAGE:EO393
CAGE:EO393
CAGE:050Q3
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 1-11%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9596
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 1-11%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 87-97%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MANGANESE (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1-11%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C, 5 MG/M3 (FUME)
ACGIH TLV:0.2 MG/M3; 9596
Ingred Name:ZINC (SARA 313) (CERCLA)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 1-11%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 1-11%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:FLUORSPAR (CALCIUM FLUORIDE)
CAS:14542-23-5
Fraction by Wt: 1-11%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2.5 MG/M3 AS F (MFG)
ACGIH TLV:2.5 MG/M3 AS F (MFG)
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV-TWA WELD FUME:5MG/M3.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:WELDING FUMES/GASES CAN BE DANGEROUS
TO HEALTH.SHORT-TERM(ACUTE)OVEREXPO TO WELDING FUMES MAY RESULT IN
DISCOMFORT SUCH AS DIZZ,NAU,DRYNESS/IRRIT OF NOSE/THROAT/EYES.LONG
TERM:SIDEROSIS(IRON DEPOSIT I N LUNGS)WHICH AFFECT PULM
FUNCTION.ARC RAYS CAN INJURE EYE/BURN SKIN.ELECTRIC SHOCK CAN KILL.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY:YES FOR NICKEL.
Effects of Overexposure:DIZZINESS, NAUSEA, DRYNESS OR IRRIT OF
NOSE/THROAT/EYES. ARC RAYS:INJURE EYE, BURN SKIN. ELECTRIC SHOCK
CAN KILL. SIDEROSIS (RION DEPOSIT IN LUNGS) WHICH AFFECTS PULM
FUNCITON.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:CALL FOR MEDICAL AID. EMPLOY FIRST AID TECHNIQUES RECOMMENDED
BY AMERCIAN RED CROSS.
===================== Fire Fighting Measures =====================
Flash Point:NA
Lower Limits:NA
Upper Limits:NA
Unusual Fire/Explosion Hazard:NON-FLAMMABLE. WELDING ARC & SPARKS CAN
IGNITE COMBUSTIBLES. REFER TO AMERICAN NATL STD 249.1 FOR FIRE
PREVENTION DURING WELDING.
======================Handling and Storage ======================
Handling and Storage Precautions:READ/UNDERSTAND MFG INSTRUCT/PRECAUT
LABEL.FILTER LENSES:RULE OF THUMB:START W/SHADE TOO DARK TO SEE
WELD ZONE,THEN GO TO NEXT LIGHTER GIVES SUFF VIEW
Other Precautions:RECOMMENDED WAY TO DETERMINE FUME/GAS COMP/QUANT
WORKERS EXPO:TAKE AIR SMPL INSIDE WELDER HELMET/WORKER BREATH
ZONE.ANSI/AWS F1.1 AVAILABLE FROM AMER WELD SOC,POB 351040,MIA,FL
33135.SEE AMER NAT STD Z-49.1 & OSHA 29CFR 1910.KEEP MATL DRY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESP WHEN WELDING IN CONFINED SPACE OR WHERE LOCAL EXHAUST OR
VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:USE ENOUGH VENTI,LOC EXHASUT @ARC OR BOTH TO KEEP
FUMES/GASES BELOW TLV IN WORKER BREATH ZONE/GENERAL AREA.
Other Protective Equipment:HELMET;SCREENS/FLASH GOGG IF NECESSARY TO
SHIELD OTHERS.HEAD/HAND/BODY PROT FROM RADIATION/SPARK/ELECTR
SHOCK.
Work Hygienic Practices:TRAIN WELDER TO KEEP HEAD OUT OF FUMES/NOT
TOUCH LIVE ELCTRICAL PARTS/INSULATE HIMSELF FROM WORK/GROUND.
Supplemental Safety and Health
HAZ DECOMP PROD:USED.ALSO COAT ON METAL BEING WELDED,#OF
WELDER/VOL,QUAL/AMT OF VENTI,POSITION OF WELDER HEAD W/FUME
PLUME,PRESENCE OF ATM CONTAMIN.DECOMP PROD:ORIGINATING FROM
VOLATIZ/RX/OXIDAT OF MA TL+BASE METAL,COAT,ETC.PRESENT AS COMPLEX
CMPDS-NOT METALS.REASONABLITY:FLOURIDES,COMPLEX FE/NI
OXIDES,CO,CO2,OZONE,NIOX
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NP
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:NA
pH:NP
Viscosity:NP
Evaporation Rate & Reference:NA
Solubility in Water:NA
Appearance and Odor:NA
Percent Volatiles by Volume:NA
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELD FUME/GAS CAN'T BE CLASSIFIED
SIMPLY.COMPO/QUANT DEPENDENT UPON METAL BEING WELD/PROCEDURES
FOLLOWED/ELECTRODE(SUPP)
==================== Disposal Considerations ====================
Waste Disposal Methods:NONE SPECIFIED BY MANUFACTURER.HMIS:DISCARD ANY
PRODUCT/RESIDUE/DISPOSAL CONTAINER/LINER IN ENVIRONMENTALLY
ACCEPTABLE MANNER APPROVED BY FED/STATE/LOC REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1345 RUST INHIBITIVE YELLOW
CAGE:KRYLO
CAGE:KRYLO
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 16%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *95-2*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 6%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *95-2*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 12%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 48%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 2%
ACGIH TLV:2 MG/CUM (RESP DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN & RESPIRATORY
SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION & DEATH. METHYL ETHYL
KETONE MAY INCREASE THE NERVOUS SYSTEM EFFECTS OF OTHER SOLVENTS.
OVEREXPOSURE TO SOLVENT MAY C AUSE ADVERSE AFFECTS TO THE
LIVER/URINARY/BLOOD FORMING/CARDIOVASCULAR & REPRODUCTIVE SYSTEMS.
(SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, UNCONSCIOUSNESS, HEADACHE,
DIZZINESS, NAUSEA, LOSS OF COORDINATION, REDNESS, ITCHING, BURNING
SENSATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH AREA THOROUGHLY W/SOAP & WATER. EYES: FLUSH
W/LARGE AMOUNTS OF WATER FOR 15 MINS. OBTAIN MEDICAL ATTETNION IN
ALL CASE S.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F
Lower Limits:1
Upper Limits:12.8
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED FOG NOZZLES ARE
PREFFERABLE.( SEE SUPP)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. EXTREMELY FLAMMABLE. VAPORS WILL
ACCUMULATE READILY & MAY IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE & REMOVE
W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAME. KEEP AREA VENTILATED. DON'T SMOKE. DON'T TAKE INTERNALLY.
USE APPROVED BONDING & GROUNDING PROCEDURES.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. CONTENTS UNDER
PRESSURE. DON'T PUNCTURE, INCINERATE/EXPOSE TO TEMP >120F.
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INAHLING THE
CONTENTS CAN BE HARMFUL/FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CAN'T BE CONTROLLED <
APPLICALBLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTER ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA.
SANDING/ABRADING: DUST/MIST RESPIRATOR APPROVED BY NIOSH/MSHA.
Ventilation:LOCAL EXHAUST: PREFERABLE/GENERAL EXHAUST: ACCEPTABLE IF
MAINTAINED < APPLICABLE EXPOSURE LIMITS.
Other Protective Equipment:SAFETY SPECTACLES W/UNPERFORATED
SIDESHIELDS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USE.
Supplemental Safety and Health
FIRE HZRD CONT'D: WATER MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT PRESSURE BUILDUP & POSSIBLE AUTOIGNITION/EXPLOSION WHEN
EXPOSED TO EXTREME HEAT. HLTH HZRD CONT'D: REPEATED/PROLONGED
OVEREXPOS URE TO SOLVENTS MAY CAUSE BRAIN & NERVOUS SYSTEM DAMAGE.
SPILLS: DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0-289F
Vapor Density:>1
Volatile Org Content %:85
Evaporation Rate & Reference:FASTER THAN ETHER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:TEMPS >120F, HEAT, SPARKS, OPEN FLAME,
SUNLIGHT, OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO2, CO, OXIDES OF METALS
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE A HAZARDOUS WASTE & MUST BE TESTED FOR
IGNITABILITY TO DETERMINE APPLICABLE EPA HAZARDOUS WASTE NUMBERS.
DON'T INCINERATE. WASTE FORM PRODUCT CONTAINING MEHTYL EHTYL KETONE
&/ZINC MAY REQUIRE T ESTING FOR EXTRACTABILITY.(SEE SUPP)
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:D 19-0 OIL STANDARD
CAGE:JOINT
CAGE:JOINT
CAGE:89771
============= Composition/Information on Ingredients =============
Ingred Name:BASE METALS CONTAINING INGREDIENT 2 - 19
RTECS #:9999999ZZ
Fraction by Wt: 0.01%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILVER;(AG) (SARA 313) (CERCLA)
CAS:7440-22-4
RTECS #:VW3500000
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ALUMINUM;(AL) (SARA 313)
CAS:7429-90-5
RTECS #:BD0330000
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST
Ingred Name:BORON;(B)
CAS:7440-42-8
RTECS #:ED7350000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3
Ingred Name:COPPER;(CU) (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CHROMIUM;(CR) (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON (FE)
CAS:7439-95-4
RTECS #:OM2100000
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5MG(FE)/M3FUME,B2
Ingred Name:MAGNESIUM(MG)
CAS:7439-95-4
OSHA PEL:15 MG/M3 PARTICULATE
ACGIH TLV:10 MG/M3; FUME
Ingred Name:MANGANESE;(MN) (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:5 MG/M3 DUST,C
ACGIH TLV:5 MG/M3 DUST
Ingred Name:NICKEL;(NI) (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:SODIUM;(NA) (CERCLA)
CAS:7440-23-5
RTECS #:VY0686000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LEAD;(PB) (SARA 313) (CERCLA)
CAS:7439-92-1
RTECS #:OF7525000
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15MG/M3 DUST
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON;(SI)
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TIN;(SN)
CAS:7440-31-5
RTECS #:XP7320000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM;(TI)
CAS:7440-32-6
RTECS #:XR1700000
OSHA PEL:0.2 MG/M3 DUST; Z-2
ACGIH TLV:0.01 MG/M3 DUST
Ingred Name:CADMIUM;(CD) (SARA 313) (CERCLA)
CAS:7440-43-9
RTECS #:ZG8600000
OSHA PEL:0.2 MG/M3 DUST;Z-2
ACGIH TLV:0.01 MG/M3 DUST
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:ZINC;(ZN)
CAS:7440-66-6
RTECS #:ZG8600000
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MOLYBDENUM;(MO)
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
Ingred Name:OIL, GRADE 1100
Fraction by Wt: >99%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) 29000 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT MAY BE IRRITATING TO THE
EYES AND MAY CAUSE SLIGHT SKIN IRRITATION. AVOID BREATHING MIST OR
AEROSOLS OF THIS PRODUCT. NOTE: LEAD APPEARS ON THE NAVY LISTING OF
OCCUPATIONAL CHEMICAL REPRO DUCTIVE HAZARDS. SEEK CONSULTATION
FROMAPPROP(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: HEALTH PROFESSIONALS CONCERNING
LATEST HAZARD LIST INFORMATION AND SAFE HANDLING & EXPOSURE
INFORMATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP). EYES: REMOVE FROM EXPOSURE SITUATION, WASH EYES FOR AT LEAST
15 MINUTES W/CLEAR WATER, SEE MD. SKIN: WASH W/SOAP & WATER. INGE
ST: DO NOT INDUCE VOMITING. CONSULT MD IF INGESTED.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:420F,216C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:TREAT AS AN OIL SPILL. CLEAN WITH TOWEL OR
RAG. DISPOSE OF RAG IN TRASH. DO NOT STORE WITH OXIDIZERS. FLOOR
MAY BE SLIPPERY. DETERGENT WASH MAY BE REQUIRED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:EXHAUST SYSTEM SHOULD BE IN PROPER WORKING ORDER TO
FURNISH NORMAL WORKPLACE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NEEDED UNLESS OIL MIST OCCURS THEN
USE DUST/MIST CARTRIDGE. USE NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN.
Ventilation:LOCAL EXHST: NOTHING BEYOND NORMAL VENTILATION.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
BOILING POINT: VERY HIGH RANGE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SUP DAT
Vapor Pres:NIL
Spec Gravity:0.9119(H*2O=1)
Solubility in Water:NIL
Appearance and Odor:PEARLESCENT BLACK COLOR, CHARACTERISTIC ODOR OF
LUBRICATING OIL.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT MIX WITH STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PARTIALLY BURNED HYDROCARBONS, METAL
OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL SPILL RESIDUES OF THESE PRODUCTS ARE NOT
CONSIDERED HAZARDOUS & MAY BE DISCARDED AS TRASH. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ECLIPSE
CAGE:FO552
CAGE:FO552
CAGE:43710
============= Composition/Information on Ingredients =============
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 3.4%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 3.8%
OSHA PEL:10 MG ZNO/M3
ACGIH TLV:10 MG ZNO/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. INHALATION:
PULMONARY SYSTEM EFFECTS & BENIGN PNEUMOCONIOSIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION. INHALATION: PULMONARY SYSTEM
EFFECTS & BENIGN PNEUMOCONIOSIS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE & OBTAIN PROMPT MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Unusual Fire/Explosion Hazard:ZINC & SILVER DUST IS A MODERATE
EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:IF LARGE QUANTITIES OF DUST ARE GENERATED, USE
INDUSTRIAL VACUUM TO CLEAN UP. MOLTEN METAL SHOULD BE ALLOWED TO
SOLIDIFY BEFORE CLEAN UP.
======================Handling and Storage ======================
Handling and Storage Precautions:PROVIDE PROTECTIVE EQUIPMENT WHEN
CUTTING, GRINDING, SOLDERING, WELDING, MELTING, MACHINING, &
HANDLING OF NON-FERROUS METALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR WHEN CUTTING, GRINDING, SOLDERING OR
WELDING.
Ventilation:LOCAL EXHAUST TO KEEP DUST, MIST OR FUMES <TLV.
Supplemental Safety and Health
ALLOY PRODUCTS ARE SOLID METALS SHAPED AS WIRE, PLATE, STRIP OR IN
FINISHED FORMS AS INGOTS, NUGGETS, ELECTRICAL CONTACT ASSEMBLIES,
SWITCHES, OR AS OTHER FORMS FOR ELECTRONIC & DENTAL USE.
================== Physical/Chemical Properties ==================
Solubility in Water:NONE
Appearance and Odor:SOLID METALS-WIRE, PLATE, STRIP, INGOTS, NUGGETS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:WELDING FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF DUST USING APPROVED METHODS
CONSISTANT W/APPLICABLE LOCAL, STATE, & FEDERAL REGULATIONS. MOLTEN
METAL SHOULD BE RECLAIMED USING STANDARD INDUSTRIAL PRACTICES SUCH
AS REMELTING & REFINING.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PLAS-T-COTE, DXM-92
CAGE:IO228
CAGE:ELIXR
CAGE:IO228
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS
CAS:64742-86-5
RTECS #:LX3296500
Fraction by Wt: 20-25%
OSHA PEL:125 PPM (MFR)
ACGIH TLV:125 PPM (MFR)
Ingred Name:FIBER
Fraction by Wt: 6%
ACGIH TLV:3 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NAUSEA, DIZZINESS, VERTIGO,
ANESTHESIA. SLIGHT SKIN IRRITATION. HARMFUL OR FATAL IF SWALLOWED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS OR
HEART CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES AND SKIN: FLUSH WITH COPIOUS AMOUNTS OF WARM WATER FOR
AT LEAST 15 MIN. INHAL: REMOVE VICTIM TO FRESH AIR AND ADMINISTER
CPR IF BREATHING HAS STOPPED. NOTIFY PHYSICIAN IMMEDIATELY. INGEST:
DO NOT INDUCE VOMITING. NOTIFY PHYSICIAN IMMEDIATLEY.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:110F,43C
Lower Limits:1.1 %
Upper Limits:6.4 %
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:HANDLE AS A COMBUSTIBLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:MATERIAL WILL NOT FLOW FREELY. SCOOP UP
MATERIAL AND PLACE IN CONTAINERS. DO NOT ALLOW MATERIAL TO
CONTAMINATE SEWERS OR GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PLACE IN SEALED CONTAINERS.
Other Precautions:STORE AWAY FROM OPEN FLAMES, SPARKS AND ALL SOURCES
OF IGNITION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:LOCAL OR MECHANICAL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:GENERAL GOOD HOUSEKEEPING PROCEDURES TO BE
FOLLOWED.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>314F,>157C
Vapor Pres:5.3
Vapor Density:4.6
Spec Gravity:1.06 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:HEAVY WHITE MASTIC MILD SOLVENT ODOR.
Percent Volatiles by Volume:44
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HEAT EXTREMES, OPEN FLAMES AND SPARKS.
Hazardous Decomposition Products:CO, CO*2 INCOMPLETE COMBUSTION WILL
LIBERATE HYDROCARBON FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH ALL STATE, LOCAL, AND FEDERAL
RULES AND REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COSMOLUBE 615
Preparer's Name:ROBERT E. WILLIAMS
CAGE:73227
CAGE:73227
CAGE:73277
============= Composition/Information on Ingredients =============
Ingred Name:DIPHENYLAMINE
CAS:122-39-4
RTECS #:JJ7800000
Fraction by Wt: <1.0%
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3; 9192
Ingred Name:PETROLEUM LUBRICATING GREASE
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: NORMAL APPLICATION
OF PRODUCT AS A GREASE OR LUBRICANT SHOULD NOT CREATE INHALATION
EFFECTS OR HAZARD. SKIN: MAY BE A MILD IRRITANT TO SENSITIVE SKIN
ON PROLONGED CONTACT. EYES: MIL D IRRITANT. INGESTION: NO
SIGNIFICANT EFFECTS KNOWN. CHRONIC: UNKNOWN FOR THIS PRODUCT.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHALATION: NOT APPLICABLE. SKIN: WASH WITH SOAP AND WATER.
EYES: FLUSH WITH WATER FOR 15 MINUTES. CONSULT PHYSICIAN.
INGESTION: CONSULT PHYSICIAN. PRODUCT CONTAINS MOSTLY SILICONE
COMPOUND.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>400F,>204C
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:NONE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SHOVEL INTO A CLEAN CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH STRONG OXIDIZERS.
Other Precautions:POTENTIAL AS A POLLUTANT: NOT CONSIDERED A POLLUTANT.
EFFECTIVE WASTE DISPOSAL METHODS SHOULD BE UTILIZED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED.
Ventilation:GENERAL MECHANICAL TYPE VENTILATION IS SATISFACTORY.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V6
Vapor Pres:NIL
Spec Gravity:0.927
Solubility in Water:INSOLUBLE
Appearance and Odor:PINKISH-GRAY GREASE; BLAND ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL; OXIDES OF CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW REGULATIONS FOR DISPOSAL OF LUBRICATING
GREASES. MAY BE INCINERATED UNDER CONTROLLED CONDITIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ORBO-53 400/200 MG, 20265
Preparer's Name:CARMEN T SANTASANIA
CAGE:54968
CAGE:54968
============= Composition/Information on Ingredients =============
Ingred Name:SILICA GEL; (SILICA)
CAS:7631-86-9
RTECS #:VV7322000
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:OVEREXPOSURE TO AMORPHOUS SILICA DUSTS
OVER PROTRACTED PERIODS MAY RESULT IN PNEUMONCONIOSIS WHEREAS
CRYSTALLINE SILICAS CONTRIBUTE TO SILICOSIS. DUST MAY CAUSE
RESPIRATORY INJURY IF INHALED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER FOR AT LEAST 15 MINUTES. SKIN: FLUSH SKIN
W/LARGE VOLUMES OF WATER. INHAL: IMMEDIATELY MOVE TO FRESH AIR.
INGESTION: CALL MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:THIS MATL IS NOT FLAMMABLE OR COMBUSTIBLE.
DETERMINED BY SUPPORTING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP MATERIAL. AVOID GENERATING DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN SEALED CONTAINER IN COOL, DRY
LOCATION. KEEP AWAY FROM MOISTURE. AVOID GENERATING DUST.
Other Precautions:AVOID EYE OR SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED DUST MASK.
Ventilation:USE ONLY IN WELL VENTILATED AREA.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:4046F,2230C
Spec Gravity:2.100(H*20=1)
Appearance and Odor:COLORLESS TO WHITE GRANULES.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH ALL APPLICABLE FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ROYCO 308CA
Resp. Party Other MSDS Num.:750-002-3
Preparer's Name:NOT PROVIDED
CAGE:07950
Contract Num:SP0450-01-M-LL52
CAGE:82956
Contract Num:SP0450-99-D-0497-0006
CAGE:82956
CAGE:07950
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED LIGHT NAPHTHENIC DISTILLATE (PETROLEUM)
CAS:64742-53-6
RTECS #:PY8036000
Minumum % Wt:50.
Maxumum % Wt:70.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:SOLVENT-REFINED LIGHT NAPHTHENIC DISTILLATES (PETROLEUM)
CAS:64741-97-5
RTECS #:PY8041000
Minumum % Wt:20.
Maxumum % Wt:40.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:SOLVENT REFINED, HYDROTREATED MIDDLE DISTILLATE (PETROLEUM)
CAS:64742-46-7
RTECS #:JN9379645
< Wt:5.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:CALCIUM DINONYLNAPHTHALENESULFONATE
CAS:57855-77-3
< Wt:5.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:MINOR ADDITIVES
< Wt:4.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:BASED ON AVAILABLE TO ROYAL, THIS
PRODUCT IS NOT HAZARDOUS UNDER OSHA HAZARD COMMUNICATION
(29CFR1910.1200).
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NONE
Medical Cond Aggravated by Exposure:PREEXISTING EYE AND SKIN DISORDERS
MAY BE AGGRAVATED BY EXPOSURE TO COMPONENTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST
15 MINUTES WHILE HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN:
REMOVE CONTAMINATED CLOTHING. WIPE EXCESS FROM SKIN. FLUSH SKIN
WITH W ATER. FOLLOW BY WASHING WITH SOAP AND WATER IF IRRITATION
OCCURS, GET MEDICAL ATTENTION. DO NOT REUSE CLOTHING UNTIL CLEANED.
SLIGHT INHALATION: REMOVE VICTIM TO FRESH AIR AND PROVIDE OXYGEN IF
BREATH ING IS DIFFICULT. GIVE ARTIFICIAL RESPIRATION IF NOT
BREATHING. GET MEDICAL ATTENTION. SLIGHT INGESTION: DO NOT INDUCE
VOMITING. IF VOMITING OCCURS, KEEP HEAD BELOW HIPS TO PREVENT
ASPIRATION OF LIQUI D INTO THE LUNGS. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>148.9C, 300.F
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CO2. DO NOT
USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED ON SURFACE OF WATER.
Fire Fighting Procedures:DO NOT USE A DIRECT STREAM OF WATER. PRODUCT
WILL FLOAT AND CAN BE REIGNITED ON SURFACE OF WATER.
Unusual Fire/Explosion Hazard:NOT AVAILABLE
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RESPIRATOR AND PROTECTIVE CLOTHING AS
APPROPRIATE. SHUT OFF SOURCE OF LEAK IF SAFE TO DO SO. DIKE AND
CONTAIN. REMOVE WITH VACUUM TRUCKS OR PUMP TO STORAGE/SALVAGE
VESSELS. SOAK UP RESIDUE WITH A N ABSORBENT SUCH AS CLAY, SAND OR
OTHER SUITABLE MATERIAL. DISPOSE OF PROPERLY. FLUSH AREA WITH WATER
TO REMOVE TRACE RESIDUE. SMALL SPILLS: TAKE UP WITH ABSORBNET
MATERIAL AND DISPOSE OF PROPERLY.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES. STATIC ELECTRICITY MAY ACCUMULATE AND CREATE A FIRE
HAZARD. GROUND FIXED EQUIPMENT. BOND AND GRO UND TRANSFER
CONTAINERS AND EQUIPMENT.
Other Precautions:MINIMIZE SKIN CONTACT. WASH WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING, OR USING TOILET
FACILITIES.PROPERLY DISPOSE OF CONTAMINATED LEATHER ARTICLES
INCLUDING SHOES THAT CANNOT BE DECONTAMIN ATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATIONAL
EXPOSURE LIMITS USE A NIOSH APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE IN ACCORD WITH 29CFR1910.134. USE EITHER AN ATMOSPHERE
SUPPLYING RESPIRATOR OR AN AI R-PURIFYING RESPIRATOR FOR ORGANIC
VAPORS AND PARTICULATES.
Ventilation:NOT PROVIDED
PROTECTIVE CLOTHING AS REQUIRED TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
ABBREVIATION: N/A = NOT APPLICABLE. N/AV = NOT AVAILABLE. N/K =
UNKNOWN. N/P = NOT PROVIDED. N/R = NOT RELEVANT. N/D = NOT
DETERMINED. N/E = NOT ESTABLISHED. CNS = CENTRAL NERVOUS SYSTEM. GI
= GASTROI NTESTINAL. SCBA = SELF CONTAINED BREATHING APPARATUS.
================== Physical/Chemical Properties ==================
HCC:V6
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:NOT AVAILABLE
Vapor Density:N/AV
Spec Gravity:0.88
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT PROVIDED
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT AMBER OIL, SLIGHT HYDROCARBON ODOR
Percent Volatiles by Volume:N/AV
Corrosion Rate:NOT AVAILABLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:AVOID HEAT AND FLAME.
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID PARTICULATES AND GASES EVOLVE WHEN MATERIAL UNDERGOES
PYROLYSIS/COMBUSTION. CARBON MONOXIDE AND UNIDENTIFIED ORGANIC
COMPOUNDS MAY BE FORMED UPON COMBUSTION.
=================== Toxicological Information===================
Toxicological Information:BASED ON AVAILABLE TO ROYAL, THIS PRODUCT IS
NOT HAZARDOUS UNDER OSHA HAZARD COMMUNICATION (29CFR1910.1200).
===================== Ecological Information =====================
Ecological:NOT PROVIDED
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN AN APPROPRIATE DISPOSAL FACILITY IN
COMPLIANCE WITH LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:NOT A DOT CONTROLLED MATERIAL (UNITED STATES).
===================== Regulatory Information =====================
SARA Title III Information:NOT PROVIDED
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE EPA/TSCA INVENTORY OF CHEMICAL SUBSTANCES.
State Regulatory Information:NOT PROVIDED
======================= Other Information =======================
| 1 | gloves_mandatory |
=======================================================
Product ID: 119-361 TRANSPARENT RED OXIDE
Cage: LILLI
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: LILLI
=======================================================
Contractor Summary
=======================================================
Cage: LILLI
=======================================================
Ingredients
=======================================================
Cas: 1330-20-7
RTECS #: ZE2100000
% Wt: 11
Other REC Limits: 100 PPM
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM, SKIN
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 108-88-3
RTECS #: XS5250000
% Wt: 13
Other REC Limits: 375 MG/CUM
OSHA PEL: 100 PPM
ACGIH TLV: 50 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 78-93-3
RTECS #: EL6475000
% Wt: 6
Other REC Limits: 590 MG/CUM
OSHA PEL: 200 PPM
ACGIH TLV: 590 MG/CUM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 141-78-6
RTECS #: AH5425000
% Wt: <5
Other REC Limits: 400 PPM
OSHA PEL: 400 PPM
ACGIH TLV: 400 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 108-65-6
RTECS #: AI8925000
% Wt: 14
Other REC Limits: NOT ESTABLISHED
------------------------------
Cas: 100-41-4
RTECS #: DA0700000
% Wt: 6
Other REC Limits: 100 PPM
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: YES
Effects of Exposure: INHALATION: RESPIRATORY IRRITATION, CNS EFFECTS &
POSSIBLE ASPHYXIATION. SKIN: IRRITATION, DERMATITIS. INGESTION: GI
IRRITATION. ASPIRATION INTO LUNGS CAN CAUSE CHEMICAL PNEUMONIA WHICH CAN BE
FATAL. REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN, CNS, LIVER/KIDNEY DAMAGE.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
HEADACHE, UNCONSCIOUSNES, REDDNESS, TEARING, BLURRED VISION, DEFATTING,
NAUSEA, VOMITING, DIARRHEA.
Medical Cond Aggravated By Exposure: PRE-EXISTING EYE, SKIN, LIVER, KIDNEY
& RESPIRATORY DISORDERS.
First Aid: EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. SKIN: WASH
THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF
NEEDED. INGESTION: DON'T INDUCE VOMITING. KEEP WARM & QUIET. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: STAY UPWIND & AWAY UNLESS WEARING PROTECTIVE
EQUIPMENT. STOP &/CONTAIN DISCHARGE, SAFELY. KEEP IGNITION SOURCES AWAY.
VENTILATE AREA. USE NON-SPARKING TOOLS FOR CLEAN UP.
Waste Disposal Methods: DON'T FLUSH TO SEWER, WATERSHED/WATERWAY. DISPOSE OF
IAW/FEDERAL, STATE & LOCAL REGULATIONS. DON'T INCINERATE CLOSED
CONTAINERS. FLAMMABLE LIQUID UN 1263.
Handling And Storage Precautions: DON'T STORE >120F. STORE LARGE QUANTITIES
IN BUILDING DESIGNED TO COMPLY W/OSHA. KEEP AWAY FROM IGNITION SOURCES. KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions: KEEP CONTAINERS CLOSED WHEN NOT IN USE & IN UPRIGHT
POSITION. CONTAINERS SHOULD BE GROUNDED WHEN POURING. DON'T TAKE INTERNALLY.
EMPTIED CONTAINERS MAY CONTAIN HAZARDOUS RESIDUE & EXPLOSIVE VAPORS. KE
EP AWAY FROM IGNITION SOURCES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 21F
Lower Limits: 1
Upper Limits: 13.1
Extinguishing Media: FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures: WEAR FULL PROTECTIVE EQUIPMENT INCLUDING SCBA. WATER
SPRAY W/FOG NOZZLES IS PREFERRABLE METHOD TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY EXPLODE IF EXPOSED TO
EXTREME HEAT. VAPORS MAY BE >AIR/TRAVEL ALONG FLOOR BEFORE IGNITION,
FLASHING BACK TO SOURCE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF LIMITS ARE EXCEEDED USE NIOSH/MSHA APPROVED AIR
SUPPLIED RESPIRATOR. OSHA REGULATIONS ALSO PERMIT OTHER NIOSH/MSHA
RESPIRATORS (NEGATIVE PRESSURE TYPE) UNDER SPECIFIED CONDITIONS.
Ventilation: MECHANICAL (GENERAL/LOCAL EXHAUST) TO MAINTAIN EXPOSURE <TLVS.
Other Protective Equipment: IMPERVIOUS BOOTS & CLOTHING.
Work Hygienic Practices: REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: INTENTIONAL MISUSE BY DELIBERATELY INHALING
CONTENTS MAY BE HARMFUL/FATAL. KEEP OUT OF REACH OF CHILDREN. INDUSTRIAL USE
ONLY.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 172-279F
Vapor Density: >1
VOC Pounds/Gallon: 4.76
VOC Grams/Liter: 571
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: INSOLUBLE
Appearance and Odor: VISCOUS LIQUID W/SOLVENT ODOR.
Percent Volatiles by Volume: 64.56
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, OPEN FLAMES, STATIC ELECTRICITY, ELECTRIC
EQUIPMENT, SPARKS & OTHER IGNITION SOURCES.
Materials To Avoid: STRONG ACIDS, ALKALIES, OXIDIZERS.
Hazardous Decomposition Products: ORGANIC ACIDS, CO2, CO, SMOKE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC CONTENT: COATING/MATERIAL: 4.76 LB/GAL; 571
GM/L.
=======================================================
HAZCOM Label
=======================================================
Product ID: 119-361 TRANSPARENT RED OXIDE
Cage: LILLI
Company Name: LILLY INDUSTIES INC
Street: 2601 EAST HENRY AVENUE
Zipcode: 33610-5000
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: INHALATION: RESPIRATORY IRRITATION, CNS EFFECTS &
POSSIBLE ASPHYXIATION. SKIN: IRRITATION, DERMATITIS. INGESTION: GI
IRRITATION. ASPIRATION INTO LUNGS CAN CAUSE CHEMICAL PNEUMONIA WHICH CAN BE
FATAL. REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN, CNS, LIVER/KIDNEY DAMAGE. IRRITATION,
DIZZINESS, WEAKNESS, FATIGUE, HEADACHE, UNCONSCIOUSNES, REDDNESS, TE ARING,
BLURRED VISION, DEFATTING, NAUSEA, VOMITING, DIARRHEA.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INCOLAC II PRIMER
CAGE:1BL51
CAGE:1BL51
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 35-40%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: <2%
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 15-20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES/SKIN/INHAL: IRRITATION.
MAY CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION: HEADACHE, DIZZINESS,
FATIGUE, NAUSEA. INGEST: CAUSES NAUSEA, VOMITING, DIARRHEA,
DEPRESSED RESPIRATION. (SEE EFTS OF OV EREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:CHRONIC: LIQUID MAY CAUSE DRYING OR IRRITATION
AFTER PROLONGED EXPOSURE TO SKIN. A NUMBER OF STUDIES SUPPLIED BY
OUR TRADE ASSOC HAS INDICATED CONTINUAL OVEREXP TO CONCENTRATED
SOLVENT VAPORS OVER A P ERIOD OF TIME MAY LEAD TO PERMANENT CENTRAL
NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS,
IMPAIRED PULMONARY FUNCTIONS
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR, RESTORE BREATHING IF NEC. CONTACT
MD. EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15 MINUTES. CONTACT
MD. SKIN: WASH WITH SOAP & WATER. CONSULT MD IF IRRITATION
DEVELOPES.INGEST: DO NOT INDUCE VOMITING. IF VICTIM IS CONSCIOUS,
GIVE WATER OR MILK. CONTACT MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:55F (ETHANOL)
Extinguishing Media:FOAM, CARBON DIOXIDE, OR DRY CHEMICALS.
Fire Fighting Procedures:DO NOT USE STRAIGHT HOSE WATER STREAM. WEAR
NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT . COOL
EXPOSED CONTAINERS W/WATER
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE IF EXPOSED TO
EXTREME HEAT; ISOLATE FROM HEAT, ELECTRICAL EQUIP, SPARKS AND OPEN
FLAME. DO NOT PUT IN CONTACT WITH OXIDIZING MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:SM: USE ABSORB MATL OR SCRAPE UP DRIED MATL &
PLACE INTO CNTNRS. LG: WEAR PROT EQUIP. ELIM ALL SOURCES OF
IGNIT(OPEN FLAMES, PILOT LIGHTS, ELEC SPARKS) & VENT SPILL AREA.
CONTAIN BY DIKING TO PRVNT S PREAD. ABSORB W/SAND,EARTH,OIL DRY OR
(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNRS FROM HEAT/FLAMES & DIRECT
SUNLIGHT.DO NOT STORE AT TEMPS >120F. PROVIDE CROSS VENT IN STOR
AREA. KEEP CNTNRS TIGHTLY CLSD WHEN NOT IN USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. CNTNS FLAM SOLV. VAPOR
HARMFUL & MAY CAUSE FLASH FIRE. HARMFUL/FATAL IF SWALLOWED. USE
ONLY W/ADEQ VENT & ELIM SOURCES OF IGNIT WHEN PROD IS USED. AVOID
PRLNGD/RPTD BRTH G OF SOLV VAPORS & CONT W/SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED FOR ANY COMPONENT, USE
APPROVED NIOSH/MSHA RESPIRATOR. CONSULT YOUR SAFETY EQUIPMENT
SUPPLIER & OSHA REGULATION, 29 CFR 1910.134 FOR RESPIRATOR
REQUIREMENTS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL VENTILATION (LOCAL OR GENERAL
EXHAUST) TO MAINTAIN EXPOSURE BELOW PEL & TLV)
Other Protective Equipment:PROVIDE EYEWASH & SOLVENT IMPERVIOUS APRON
IF BODY CONTACT WITH PRODUCT MAY OCCUR. BARRIER CREAMS MAY BE USED.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
SPILL PROC: OTHER ABSORBENT MATERIAL & SHOVEL INTO CONTAINERS. CLEAN UP
REMAINING SPILLAGE BY WASHING W/NONFLAMMABLE SOLVENT SUCH AS
1,1,1-TRICHLOROETHANE. PREVENT RUN-OFF TO SEWERS, STREAMS, LAKES, O
R OTHER BODIES OF WATER; NOTIFY LOCAL HEALTH & WILDLIFE OFFICIALS
IF RUN-OFF OCCURS.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:147F,64C
Spec Gravity:0.79
Solubility in Water:LIMITED
Appearance and Odor:WHITE LIQUID WITH A MILD ODOR.
Percent Volatiles by Volume:40-48
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND CAUSTICS.
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:NORMAL COMBUSTION PRODUCTS, I.E. CO*X,
NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARDED SPILL RESIDUE MAY BE INCINERATED. DO
NOT INCINERATE SEALED CNTNRS. DISPOSE ACCORDING TO FEDERAL, STATE &
LOCAL REGULATIONS. LIQUIDS CANNOT BE DISPOSED OF IN A LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BLACK DEVELOPER FOR DC111, ETC
CAGE:0AH08
CAGE:79775
CAGE:0AH08
CAGE:65678
============= Composition/Information on Ingredients =============
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 70%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:ZINC OXIDE
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
Ingred Name:MAGNESIUM OXIDE
CAS:1309-48-4
RTECS #:OM3850000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 PARTICULATE
ACGIH TLV:10 MG/M3;TDUST; 9293
Ingred Name:CUPRIC OXIDE
CAS:1317-38-0
RTECS #:GL7900000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG CU/M3
ACGIH TLV:1 MG CU/M3
Ingred Name:BLACK TONER FOR DC-111
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50 IS NOT KNOWN
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS PRACTICALLY NON-TOXIC. IT
PRODUCES PHYSICAL IRRITATION OF BODY TISSUES. RESPIRATORY
IRRITATION MAY OCCUR IF LARGE AMOUNTS OF DUST ARE INHALED.
Explanation of Carcinogenicity:THE PRODUCT CONTAINS NO INGREDIENT THAT
IS LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE:PHYSICAL IRRITATION SKIN:POSSIBLE
IRRITATIONINHALED:RESPIRATORY IRRITATION WITH EXPOSURE TO LARGE
AMOUNTS OF DUST. INGESTED:NOT REPORTED.
Medical Cond Aggravated by Exposure:NONE REPORTED
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE. INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING IF
NECESSARY.INGESTED:D O NOT INDUCE VOMITING. GIVE 2 LARGE GLASSES
OF MILK OR WATER AND GET IMMEDIATE MEDICAL CARE. GIVE NOTHING BY
MOUTH IF UNCONSCIOUS. IF IRRITATION PERSISTS OR IS SEVERE,SEE A
DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NOT RELAVANT
Extinguishing Media:USE CARBON DIOXIDE,
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP BEING CAREFUL TO CREATE AS LITTLE
DUST AS POSSIBLE OR VACUUM.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, DARK AREA. KEEP
TIGHTLY CLOSED.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED RESPIRATOR FOR DUST IF EXPOSURE IS ABOVE THE
TLV/PEL FOR NUISANCE DUST.
Ventilation:NOT NORMALLY REQUIRED.
Other Protective Equipment:NONE REQUIRED
Work Hygienic Practices:USE OF GOOD PERSONAL HYGIENE PRACTICES IS
SUFFICIENT. AVOID INHALATION,INGESTION OR SKIN CONTACT IF POSSIBLE.
Supplemental Safety and Health
BLACK DEVELOPER IS USED FOR MODELS
DC-211,213RE,313Z,313ZD,4055,4085,2105.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:POWDER
pH:UNKNON
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FINE BLACK POWDER, PRACTICALLY ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE GIVEN BY MANUFACTURER (SUPPLIER).
Hazardous Decomposition Products:NONE GIVEN BY MANUFACTURER (SUPPLIER).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL FEDERAL, STATE AND LOCAL
REGULATIONS. DGSC-SSH SUGGESTS THAT DISPOSAL MAY BE DONE AS THOUGH
PRODUCT WERE ORDINARY REFUSE.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & NATURAL/SYNTHETIC RUBBER COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ALUMINUM BROWN GL
CAGE:FO456
CAGE:1Y044
CAGE:FO456
============= Composition/Information on Ingredients =============
Ingred Name:MFR STATES: NON-HAZARDOUS INGREDIENTS AND FORMULA IS
PROPRIETARY
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:NONE KNOWN (MFR)
======================= First Aid Measures =======================
First Aid:FLUSH EYES WITH PLENTY OF WATER, GET MEDICAL ATTN. WASH SKIN
WITH SOAP & WATER. IF INGESTED GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER,FOAM,DRY CHEMICALS,CO*2
Fire Fighting Procedures:NONE (MFR)
Unusual Fire/Explosion Hazard:DUST MAY BE EXPLOSIVE IF MIXED WITH AIR
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AND PLACE IN A WASTE DISPOSAL
CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:LOCAL/MECHANICAL
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:SOLUBLE
Appearance and Odor:DARK BROWN POWDER,MILD CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CO,CO*2
==================== Disposal Considerations ====================
Waste Disposal Methods:BY METHODS CONSISTENT WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:8048748 VIOLET 59-H
CAGE:DO804
CAGE:DO804
CAGE:38360
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL BUTYL ETHER ACETATE, ETHANOL, 2-
(2-BUTOXYETHOXY), BUTYL CARBITOL ACETATE
CAS:124-17-4
RTECS #:KJ9275000
Fraction by Wt: 10-25%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATE IRRITATION. SKIN:
SLIGHT IRRITATION. INHALATION: NASAL & RESPIRATORY IRRITATION, CNS
EFFECTS, DEATH. INGESTION: GI IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, UNCONSCIOUSNESS, VOMITING, DIARRHEA, REDNESS,
TEARING.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. INGESTION: IF CONSCIOUS GIVE 2
GLASSES OF WATER & INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:237F
Extinguishing Media:DRY CHEMICAL, CO2, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPORS ARE >AIR & MAY TRAVEL ALONG GROUND
TO DISTANT IGNITION SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. ABSORB MATERIAL
W/VERMICULITE/FLOOR ABSORBENT. DISPOSE OF CONTAMINATED MATERIALS
======================Handling and Storage ======================
Handling and Storage Precautions:FOR FLAMMABLE/COMBUSTIBLE PRODUCTS,
FOLLOW STORAGE & HANDLING GUIDELINES PRESENT IN NFPA 30 FLAMMABLE &
COMBUSTIBLE LIQUIDS CODE.
Other Precautions:CONTAINERS MAY BE HAZARDOUS WHEN EMPTIED, SINCE
EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES WHICH CAN GENERATE
VAPORS W/IN FLAMMABLE LIMITS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:SUFFICIENT TO MAINTAIN OPERATOR EXPOSURE <APPLICABLE
OCCUPATIONAL EXPOSURE STANDARDS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
USE OF A HAZARDOUS CHEMICAL MAY REQUIRE SUPPLEMENTAL VENTILATION FOR
PROTECTION OF PERSONNEL & FOR CONTROLLING FIRE/EXPLOSION HAZARD. A
QUALIFIED INDEPENDENT TESTING COMPANY CAN DETERMINE IF EXISTING
CONCENTRATIONS ARE W/IN ESTABLISHED RECOMMENDED/PERMISSIBLE
EXPOSURE LEVELS.
================== Physical/Chemical Properties ==================
Vapor Pres:<0.01
Evaporation Rate & Reference:(N-BU AC = 1): <0.01
Solubility in Water:NEGLIGIBLE
Appearance and Odor:VIOLET LIQUID/SEMI-SOLID INK W/MILD ODOR.
Percent Volatiles by Volume:15
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES/MINERAL ACIDS.
Stability Condition to Avoid:HEAT, FLAME & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO & CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. IT'S THE RESPONSIBILITY OF THE GENERATOR OF THE WASTE
TO DETERMINE WHETHER THE WASTE GENERATED MEETS THE FEDERAL/STATE
HAZARDOUS WASTE CRITERIA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TECTYL 828
CAGE:81355
CAGE:81355
============= Composition/Information on Ingredients =============
Ingred Name:ORGANIC SALT (CONTAINS METAL SULFONATE-MAY CAUSE ALLERGIC
SKIN REACTION PEL/TLV IS FOR OIL MIST)
CAS:61789-86-4
Fraction by Wt: 1-10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3;STEL 10MG/M3
Ingred Name:PETROLEUM HYDROCARBON (PEL/TLV IS FOR OIL MIST)
CAS:8009-03-8
Fraction by Wt: 25-40%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3;STEL 10MG/M3
Ingred Name:ALIPHATIC PETROLEUM DISTILLATES (PEL/TLV IS FOR OIL MIST)
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: 10-25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3;STEL 10MG/M3
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:EYES: MAY CAUSE IRRITATION. SKIN:
PROLONGED OR REPEATED EXPOSURE MAY CAUSE IRRITATION & DERMATITIS.
SWALLOWING: MAY CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING
& DIARRHEAA. INHALATION: INNHALA TION OF MIST MAY CAUSE IRRITATION
OF NASAL & RESPIRATORY PASSAGES.
======================= First Aid Measures =======================
First Aid:SKIN: THOROUGHLY WASH EXPOSED AREA WITH SOAP & WATER. REMOVE
CONTAMINATED CLOTHING. LAUNDER CONTAMINATED CLOTHING BEFORE RE-USE.
EYES: FLUSH WITH LARGE AMOUNTS OF WATER, LIFTING UPPER & LOWER LIDS
OCC ASIONALLY. GET MEDICAL ATTENTION. IF IRRITATION PERSISTS.
INGESTION: DO NOT INDUCE VOMITING. KEEP PERSON WARM & QUIET, GET
MEDICAL ATTENTION. INHALATION: REMOVE INDIVIDUAL TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:460F,238C
Extinguishing Media:REGULAR FOAM OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WATER OR FOAM MAY CAUSE FROTHING WHICH CAN BE
VIOLENT & ENDANGER LIFE OF FIREFIGHTER,ESPECIALLY IF SPRAYED INTO
CONTAINERS OF HOT BURNING LIQUID.
Unusual Fire/Explosion Hazard:NEVER USE WELDING, CUTTING TORCH ON/NEAR
DRUM (EVEN EMPTY) BECAUSE PRODUCT/RESIDUE CAN IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL:ABSORB LIQ ON VERMIC,FLOOR
ABSORB,ETC.LRG:EXCLUDE UNPROTECTED TILL CLEAN UP COMPLETE.STOP
SPILL AT SOURCE,DIKE TO PREVENT SPREADING.PUMP LIQ TO SALVAGE
TANK.TAKE UP REMAINING ON SAND/ETC.SHOVEL INTO CNTNRS.PREVENT
RUNOFF TO SEWER,WATERBODIES. *
Neutralizing Agent:N/K * IF RUNOFF OCCURS, NOTIFY AUTHORITIES AS
REQ'D.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES &
PROLONGED/REPEATED CONTACT WITH SKIN. WEAR SAFETY GLASSES OR
Other Precautions:DON'T TRANSFER TO UNLABELED CNTNR.MINIMIZE EXPOSURE
THRU GOOD HYGENIC PRACTICES.DON'T USE CUTTING/WELDING TORCH ON
CONTAINER (EVEN EMPTY).USE/STORE ONLY WITH ADEQUATE VENT. BEFORE
USE,REVIEW MSDS FOR MORE INFO. FOR INDUSTRIAL USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKPLACE EXPOSURE LIMITS OF PRODUCT IS
EXCEEDED, A NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR ADVISED IN
ABSENCE OF PROPER ENVIRONMENTAL CONTROLS. OSHA REGS ALSO PERMIT
OTHER RESPIRATOR (NEG PRES SR) UNDER SPECIFIED CONDITIONS. *
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS AND LEGS.
Supplemental Safety and Health
* SEE YOUR INDUSTRIAL HYGIENIST. ENGINEERING OR ADMINISTRATIVE CONTROLS
SHOULD BE IMPLEMENTED.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:425F,218C
Vapor Pres:0.10 @ 68F
Vapor Density:> AIR
Spec Gravity:0.890 @ 60.0F
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:UNSPECIFIED APPEARANCE IN A SEMI-SOLID WAX.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
LOCAL, STATE, ADN FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:9071 METHYL ALCOHOL
Resp. Party Other MSDS Num.:LABCO SCIENTIFIC DIV OK 73104
CAGE:70829
CAGE:1A109
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ALCOHOL
CAS:67-56-1
RTECS #:PC1400000
= Wt:100.
OSHA PEL:260 MG/M3;200 PPM
ACGIH TLV:262 MG/M3;200 PPM
ACGIH STEL:328 MG/M3;250 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 5628 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO
Health Hazards Acute and Chronic:INHALATION: IRRITANT TO MUCOUS
MEMBRANES. TOXIC TO NERVOUS SYSTEM, OPTIC NERVE. MAY CAUSE DEATH.
INGESTION: INTOXICATION, MAY CAUSE BLINDNESS, FATAL DOSE: 100-125
MILLILITERS. SKIN: ABSORPTION. EYES: MAY CAUSE LESIONS.
OVEREXPOSURE MAY CAUSE IMPAIRMENT OF VISION, ENLARGEMENT OF THE
LIVER. SKIN IRRITATION.
Effects of Overexposure:IRRITATION, HEADACHE, DROWSINESS, NAUSEA,
VOMITING, BLURRED VISION, COMA, DRY/CRACKED SKIN, EYE LESIONS.
Medical Cond Aggravated by Exposure:PERSONS W/PRE-EXISTING SKIN
DISORDERS/EYE PROBLEMS/IMPAIRED LIVER/KIDNEY FUNCTION MAY BE MORE
SUSCEPTIBLE TO THE EFFECTS OF THE SUBSTANCE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NECESSARY. INGESTION: INDUCE VOMITING IMMEDIATELY AS DIRECTED BY
PERSONNEL. NEVER GIVE ANYTHING BY MOUTH IF UNCONSCIOUS. SKIN/EYES:
IMMEDIATELY FLUS H W/PLENTY OF WATER FOR 15 MINS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:=11.1C, 52.F
Autoignition Temp:=464.C, 867.2F
Lower Limits:6
Upper Limits:36
Extinguishing Media:ALCOHOL FOAM, DRY CHEMICAL, OR CO2. WATER MAY BE
INEFFECTIVE.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING & NIOSH APPROVED SELF
CONTAINED BREATHING APPARATUS W/FULL FACEPIECE OPERATED IN THE
PRESSURE DEMAND/OTHER POSITIVE PRESSURE MODE. USE WATER SPRAY TO
BLANKET FIRE, COOL FIRE E XPOSED CONTAINERS & TO FLUSH NON-IGNITED
SPILLS/VAPORS AWAY FROM FIRE.
Unusual Fire/Explosion Hazard:VAPORS CAN FLOW ALONG SURFACES TO DISTANT
IGNITION SOURCES & FLASHBACK. ABOVE FLASHPOINT, VAPOR-AIR MIXTURES
ARE EXPOSIVE W/IN FLAMMABLE LIMITS. MODERATE EXPLOSION HAZARD &
DANGEROUS FIRE HAZARD WHENEXPOSED TO HEAT, SPARKS/FLAMES.
SENSITIVE TO STATIC DISCHARGE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE ALL SOURCES OF
IGNITION. WEAR PROTECTIVE EQUIPMENT. ISOLATE AREA. KEEP UNPROTECTED
PERSONNEL FROM ENTERING. CONTAIN/RECOVER LIQUID. USE NON-SPARKING
TOOLS & EQUIPMENT. COLLECT L IQUID IN APPROPRIATE CONTAINER/ABSORB
W/AN INERT MATERIAL & PLACE IN A CHEMICAL WASTE CONTAINER. DON'T
USE SAWDUST. DON'T FLUSH TO SEWER. IF NO LEAK HAS IGNITED, USE
WATERSPRAY TO DISPERSE VAPORS.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE. STORE
IN A COOL, DRY WELL-VENTILATED LOCATION AWAY FROM FIRE HAZARD.
SEPARATE FROM INCOMPATIBLES. CONTAINERS SHOULD BE BONDED & GROUNDED
FOR TRANSFERS. STORAGE SHOULD BE NO SMOKING. USE NON-SPARKING
TOOLS/EQUIPMENT/EXPLOSION PROOF VENTILATION.
Other Precautions:CONTAINERS W/THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY SINCE THEY RETAIN PRODUCT RESIDUES; OBSERVE ALL WARNINGS &
PRECAUTIONS. DON'T ATTEMPT TO CLEAN EMPTY CONTAINERS. DON'T
PRESSURIZE, CUT, WELD, BRA ZE, SOLDER, DRILL, GRIND/EXPOSE
CONTAINERS TO HEAT/SPARKS/FLAME/STATIC ELECTRICITY/OTHER SOURCES OF
IGNITION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE LIMIT IS EXCEEDED, WEAR A SUPPLIED
AIR, FULL-FACEPIECE RESPIRATOR, AIRLINED HOOD/FULL-FACEPIECE SELF
CONTAINED BREATHING APPARATUS.
Ventilation:PROVIDE GENERAL/LOCAL EXHAUST VENTILATION TO KEEP <AIRBORNE
EXPOSURE LIMITS TO CONTROL EMISSIONS & PREVENT DISPERSION OF
CONTAMINANTS.
Other Protective Equipment:EYE WASH FOUNTAIN, QUICK-DRENCH FACILITIES,
IMPERVIOUS BOOTS, APRON, COVERALLS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. THOROUGHLY CLEAN SHOES BEFORE REUSE.
Supplemental Safety and Health
POISON! DANGER! VAPOR HARMFUL. MAY BE FATAL/CAUSE BLINDNESS IF
SWALLOWED. HARMFUL IF INHALED/ABSORBED THROUGH SKIN. CANNOT BE MADE
NONPOISONOUS. FLAMMABLE LIQUID & VAPOR. CAUSES IRRITATION TO SKIN,
EY ES & RESPIRATORY TRACT. AFFECTS CNS & LIVER.
================== Physical/Chemical Properties ==================
Boiling Pt:=64.5C, 148.1F
Melt/Freeze Pt:=-98.C, -144.4F
Vapor Pres:97
Vapor Density:1.1
Spec Gravity:0.8
Evaporation Rate & Reference:(BUAC=1): 5.9
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID W/CHARACTERISTIC ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS NITRATES, PERCHLORATES/SULFURIC ACID,
PLASTICS, RUBBER & COATINGS, METALLIC ALUMINUM
Stability Condition to Avoid:HEAT, SPARKS, FLAMES, OTHER IGNITION
SOURCES, STATIC DISCHARGE
Hazardous Decomposition Products:HYDROGEN GAS, CO2, CO, FORMALDEHYDE
=================== Toxicological Information===================
Toxicological Information:INVESTIGATED AS A MUTAGEN, REPRODUCTIVE
EFFECTOR.
===================== Ecological Information =====================
Ecological:WHEN RELEASED INTO THE SOIL, THIS MATERIAL CAN READILY
BIODEGRADE, LEACH INTO GROUNDWATER, MAY QUICKLY EVAPORATE. WHEN
RELEASED INTO THE WATER, THIS MATERIAL MAY HAVE A HALF-LIFE BETWEEN
1-10 DAYS/BIO DEGRADE. WHEN RELEASED INTO THE AIR, THIS MATERIAL IS
EXPECTED TO BE READILY DEGRADED BY REACTION W/PHOTOCHEMICALLY
PRODUCED HYDROXYL RADICALS & HAVE A HALF-LIFE BETWEEN 10-30
DAYS/MAY BE REMOVED FROM THE ATMOSPHERE BY WET DEPOSITION. THIS
MATERIAL IS EXPECTED TO BE SLIGHTLY TOXIC TO AQUATIC LIFE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECOVERY/RECYCLED
SHOULD BE HANDLED AS HAZARDOUS WASTE & SENT TO RCRA APPROVED
INCINERATOR/DISPOSED IN A RCRA APPROVED WASTE FACILITY. DISPOSE OF
IN ACCORDANCE W/LOCAL, ST ATE & FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:METHANOL. UN1230, PACKING GROUP II. INFORMATION
REPORTED FOR PRODUCT/SIZE: 350 LBS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HYCAR NITRILE ELASTOMERS
CAGE:HO778
CAGE:4248X
CAGE:HO778
============= Composition/Information on Ingredients =============
Ingred Name:ING 12:DO NOT STORE/CONSUME FOOD IN PROCESSING AREAS.DO NOT
USE PROCESSING EQUIP TO HEAT FOOD. CLEANUP FOLLOWING(ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:NORMAL PROCESSING SHOULD BE PERFORMED UNDER
WELL-VENT CNDTNS.THE ELASTOMER MAY BE HELD AT PROCESS TEMPS (ING
15)
RTECS #:9999999ZZ
Ingred Name:ING 14:FOR SHORT TIME W/O SIGNIFICANT THERMAL
DEGRADATION.HOWEVER, IT SHOULD BE RECOGNIZED THAT EXPOS TO
EITHER(ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:ELEV TEMP/EXCESSIVE HEAT HISTORY (TIME) WILL RESULT
IN DECOMP.EQUIP SHOULD NOT BE SHUT DOWN FOR EXTENDED (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:TIME PERIOD W/CMPD IN IT/DECOMP WILL OCCUR.MATL NOT
USED WITHIN 1 YR SHOULD BE TESTED TO DETERMINE IF (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:DEGRADATION HAS OCCURRED.CMPD INGRED PURCHASED TO
ADD TO ELASTOMER MAY REQ SPECIAL HNDLG.IT IS THE USER'S(ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:RESPONSBILITY TO FOLLOW THE REC PREC OF INDIVIDUAL
ADDITIVE SUPPLIERS.POST-PROCESSING OPER @ WORKPLACE/ (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:@ CUSTOMER'S WORKPLACE INVOLVING HEAT SUFF TO RESULT
IN POLYMER BREAKDOWN EMITTING SMOKE & FUMES SHOULD (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:ALWAYS BE CONDUCTED IN SUCH A MANNER TO AVOID INHAL
OF FUMES.LOC EXHST VENT SHOULD BE PROVIDED TO PVNT (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21:SIGNIFICANT EMPLOYEE EXPOS.ABNORMAL CNDTNS SUCH AS
EQUIP MALFUNC/USING IMPROPER EQUIP/PROC/HANGUP OR (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 22:STAGNATION OF MATL DURING PROCESS MAY CAUSE
DECOMP.EMPLOYEES INVOLVED IN REMOVING DECOMP MATL SHOULD BE(ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23:PROVIDED SUITABLE AIR-SUPPLIED RESP, SUCH AS
NIOSH/MSHA APPRVD POSITIVE PRESS SCBA.
RTECS #:9999999ZZ
Ingred Name:EXPLAN-CARCIN: GROUP 2B (IARC); GROUP 2 (NTP).
RTECS #:9999999ZZ
Ingred Name:ACRYLONITRILE
CAS:107-13-1
RTECS #:AT5250000
Fraction by Wt: <20% PPM
OSHA PEL:SEE 1910.1045
ACGIH TLV:S, 2 PPM;A2 9394
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:1,3-BUTADIENE; (BUTADIENE)
CAS:106-99-0
RTECS #:EI9275000
Fraction by Wt: <5% PPM
OSHA PEL:1000 PPM
ACGIH TLV:10 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PHTHALIC ACID, BIS(2-ETHYLHEXYL) ESTER;
(DI-2-ETHYLHEXYL-PHTHALATE)
CAS:117-81-7
RTECS #:TI0350000
Fraction by Wt: 33%
OSHA PEL:5MG/M3;10 MG/M3 STEL
ACGIH TLV:5MG/M3;10 MG/M3 STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:TALC POWDER, CONTAINING NO ASBESTOS FIBERS; (TALC)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 3-7%
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:EXPLO HAZ:VERTICAL TUBE APPARATUS.THESE ELASTOMERS DO NOT
CONTAIN "FINES", OR DUST, OF SUFF PARTICLE SIZE/AMT TO(ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:PROPAGATE IGNIT BY THIS METHOD OF
TEST.CAUTION:GRINDING CRUMB/POWDER ELASTOMERS MAY PRODUCE PARTICLES
SM (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:ENOUGH TO CREATE A DUST EXPLO POTENTIAL.AS THE NEED
EXISTS,ELEMENT STANDARD SAFETY PREC FOR HNDLG FINELY (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:DIVIDED POWDERS SUCH AS ELIM LIKELY SOURCES OF
IGNIT,INCL STATIC BUILDUP, PROVIDING ADEQ VENT, PROPERLY (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: MAINTAINING & OPER DUST CONTROL DEVICES & PROPERLY
BONDING & GROUNDING PROCESSING EQUIPMENT.
RTECS #:9999999ZZ
Ingred Name:HAZ DECOMP PRODS: LIKE THOSE OF OTHER NATURAL AND SYNTHETIC
MATERIALS, MUST BE CONSIDERED TOXIC.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: THE EFFECTIVENESS OF EXHAUST VENTILATION
PROVIDED TO THE PROCESS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:ALWAYS USE HYCAR NBR ELASTOMER UNDER WELL-VENT
CNDTNS & AVOID CONTINUED/PRLNGD BRTHG OF PROCESS VAPS.(ING 13)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE & CHRONIC:NONE EXPECTED FOR
SLAB/ CRUMB/POWDER AS DELIVERED. TALC (GROUND RUBBER GRADES) MAY
CAUSE IRRIT OF EYES IN THE SAME MANNER AS NUISANCE DUST. RPTD INHAL
OF TALC CAN CAUSE SHORTNESS OF BR EATH/CHRONIC COUGH. NO ADVERSE
HLTH EFTS NOR EXPOS TO SIGNIFICANT AMTS OF RESIDUAL MONOMERS ARE
EXPECTED(EFTS OF OVEREXP
Explanation of Carcinogenicity:DI-SEC-OCTYL PHTHALATE: GRP 2B (IARC);
GRP 2 (NTP). ACRYLONITRILE: GRP 2A (IARC); GRP 2 (NTP).
1,3-BUTADIENE: (ING 25)
Effects of Overexposure:HLTH HAZ:WHEN POTENTIAL EXPOS ARE MINIMIZED
DURING PROCESSING BY GOOD INDUSTRIAL HYGIENE PRACTICE & ADEQ VENT.
NEVERTHELESS, AT PROCESSING TEMPS, ELASTOMERS MAY EMIT FUMES & VAPS
THAT MAY CAUSE EYE/RE SP TRACT IRRIT. ANY EFT WILL DEPEND UPON
PROCESSING TECHNIQUE & TEMP, VOLUME PROCESSED & MOST IMPORTANTLY,
(ING 11)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: IF IRRITATION PERSISTS FROM EXPOSURE TO PROCESSING
VAPORS OR DECOMPOSITION PRODUCTS, REMOVE THE AFFECTED INDIVIDUAL
FROM THE AREA. CALL MD. PROVIDE PROT BEFORE ALLOWING REENTRY.
INGEST: CALL MD IMMEDIATELY . EYES: IMMEDIATELY FLUSH EYES WITH
POTABLE WATER FOR A MINIMUM OF 15 MIN, SEEK ASSISTANCE FROM MD .
SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER. ABC DRY CHEM. PROTEIN TYPE AIR FOAMS. THIS
PRODUCT IS CONSIDERED "ORDINARY COMBUST" (NFPA CLASS A). (SUPP
DATA)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. PERS NOT HAVING SUITABLE RESP PROT MUST LEAVE AREA TO PVNT
SIGNIFICANT EXPOS TO TOXIC COMBUST (SUPP DATA)
Unusual Fire/Explosion Hazard:NONE EXPECTED FOR ELASTOMER AS DELIVERED.
CRUMB & POWDER HYCAR NITRILE ELASTOMERS DO NOT REPRESENT A DUST
EXPLO HAZ BASED ON TESTS USING THE HARTMANN (ING 5)
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP SLABS. VACUUM OR SWEEP ANY CRUMBS OR
CHUNKS INTO A CONTAINER FOR REUSE OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
DIRECT LIGHT TO MAINTAIN OPTIMUM QUALITY.
Other Precautions:NORMAL MELT PROCESSING.VIRTUALLY ALL ELASTOMERS WILL
EMIT FUMES AND/OR VAPS WHEN HEATED TO PROCESSING TEMPS. THE CONC &
COMPOSITION OF THESE VAPS WILL DEPEND UPON VARIABLES SUCH AS THE
SPECIFIC FORMUL ATION & PROCESSING METHOD/TEMP. (ING 12)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR RESP APPRVD BY NIOSH/MSHA WHENEVER EXPOS TO
FUMES/VAPS EXCEED LIMS LISTED IN ING SECTION.WHEN PROT AGAINST DUST
IS NEC, WEAR PARTICULATE RESP APPRVD BY NIOSH/MSHA.USE I/A/W MFR
USE LIMITATIONS & OSHA STANDARD 1910.134 (29CFR).
Ventilation:PROVIDE ADEQUATE VENTILATION TO MAINTAIN AMBIENT WORKPLACE
ATMOSPHERE BELOW TLV/PEL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER PROCESSING CMPD, ESP
BEFORE EATING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
EXT MEDIA: CO2 IS GENERALLY NOT REC FOR USE ON CLASS A FIRES AS A LACK
OF COOLING CAPACITY MAY RESULT IN REIGNIT. FIRE FIGHT PROC:GASES
FROM ANY SOURCE.IN ENCLSD/POORLY VENT AREAS, WEAR SCBA DURING CL
EANUP IMMED AFTER FIRE AS WELL AS DURING ATTACK PHASE OF
FIREFIGHTING OPER.
================== Physical/Chemical Properties ==================
HCC:T6
Spec Gravity:0.95-1.02
Solubility in Water:INSOLUBLE
Appearance and Odor:TAN TO BROWN SLAB, CRUMB/POWDER. A MILD ODOR IS
CHARACT FOR ALL PRODUCTS.
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO2 & SMALL AMTS OF OXIDES OF
NITROGEN, AROMATIC & ALIPHATIC HYDROCARBONS. COMBUST PRODS FROM
RUBBER, (ING 10)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGS. FOR WASTE DISP PURPOSES THESE PRODUCTS ARE
NOT DEFINED OR DESIGNATED AS HAZ BY CURRENT PROVISIONS OF THE
FEDERAL (U.S.E.P.A.) RCRA 40 CFR261.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:#39999-00G COMPLT SET OF MICROCHEM,SODIUM THIOCYANATE 0.1M
Kit Part:Y
Preparer's Name:R.M. CARLSON
CAGE:CNTRL
CAGE:CNTRL
CAGE:11273
CAGE:CENC1
CAGE:CENC3
CAGE:CENC2
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM THIOCYANATE
CAS:540-72-7
RTECS #:XL2275000
Fraction by Wt: 0.8%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MODERATLY CAUSTIC
SOLUTION.ACUTE:IRRITATION POSSIBLE TO SKIN AND EYES.CHRONIC:NONE
KNOWN.
Effects of Overexposure:(WHEN IN DOUBT CALL PHYSICIAN OR LOCAL POISON
CONTROL CENTER). IRRITATION SKIN AND EYES.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:SKIN:WASH THOROUGHLY W/RUNNING WATER.IRRIT DVLPS GET MED
ADVICE.EYE:WASH W/PLENTY OF H2O @LEAST 15MINS,LIFT EYELIDS
OCCASION.GET MED ATTN IMMED.INHAL:NOT EXPECTED TO REQUIRE 1STAID
MEASURES.INGEST:IND UCE VOMIT IMMED BY GIVING 2GLASSES OF H2O,STICK
FINGER DOWN THROAT.NEVER GIVE ANYTHING BY MOUTH IF UNCONSC.CALL DR
IMMED.
===================== Fire Fighting Measures =====================
Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NP
Upper Limits:NP
Extinguishing Media:USE ANY MEDIUM SUITABLE FOR EXTINGUISHING
SUPPORTING FIRE.
Fire Fighting Procedures:IN EVENT OF FIRE WEAR FULL PROTECTIVE CLOTH &
NIOSH-APPROV SELF-CONTAIN BREATH APPARATUS W/FULL FCPIECE OPERATED
IN PRESSURE DEMAND OR OTHER +PRESSURE MODE.
Unusual Fire/Explosion Hazard:NOT CONSIDERED TO BE FIRE/EXPLOSION
HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE AND NEUTRALIZE WITH DILUTE
ACID.CLEANUP/DISPOSAL METHODS ARE RECOMMENDATIONS ONLY.CHECK YOUR
LOCAL,STATE,AND FEDERAL REGULATIONS.
Neutralizing Agent:DILUTE ACID.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY LOCATION.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED NORMALLY.
Ventilation:LOCAL EXHAUST AND MECHANICAL(GENERAL).
Other Protective Equipment:LAB COAT
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PC:39966-00. KEY1:HCC=T6. PER MFG KIT NOT MANUFACTURED ANY
MORE,SIZE=50ML.SEE OTHER PARTS @CAGES:11273,CENC1,CENC2,CENC3,CENC4
ALL PNIND W/SAME NSN.
================== Physical/Chemical Properties ==================
HCC:V1
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Decomp Temp:Decomp Text:NP
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:1
pH:NP
Viscosity:NP
Evaporation Rate & Reference:NA
Solubility in Water:100
Appearance and Odor:CLEAR SOLUTION, NO ODOR
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH DOWN DRAIN W/EXCESS OF
WATER.CLEANUP/DISPOSAL METHODS ARE RECOMMENDATIONS ONLY.CHECK YOUR
LOC/STATE/FED REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & STEEL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HOUSEHOLD AMMONIA
CAGE:0EK53
CAGE:0EK53
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIA (SARA III)
CAS:7664-41-7
RTECS #:BO0875000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM
ACGIH TLV:25 PPM/35 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50:
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE IRRITATION OF THE
RESPIRATORY TRACT. EYE AND SKIN IRRITANT. TOXIC BY INGESTION.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:MAY CAUSE EYE, SKIN & RESPIRATORY TRACT
IRRITATION. MAY ALSO CAUSE HEADACHE, DIZZINESS AND NAUSEA.
ASPIRATION PNEUMONITIS MAY CAUSE COUGHING, LABORED BREATHING,
CYANOSIS, AND IN SEVERE CASES, DEATH.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION IMMEDIATELY. SKIN: WASH WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL ADVICE.
INHALATIO N: REMOVE TO FRESH AIR. GIVE MOUTH-TO-MOUTH RESUSCITATION
IF NOT BREATHING. GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. RINSE MOUTH & DRINK LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. FLUSH AWAY SPILLED PRODUCT
WITH WATER WHEN VAPORS WILL PERMIT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, VENTILATED AREA.
KEEP OUT OF DIRECT SUNLIGHT. AVOID OVERHEATING.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF AMMONIA VAPORS AREA GREATER THAN 300 PPM,
WEAR A NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE RESPIRATOR WITH FULL
FACEPIECE AND ORGANIC VAPOR CARTRIDGES IN COMBINATION WITH A
HIGH-EFFICIENCY PARTICULATE FILTER.
Ventilation:LOCAL AND MECHANICAL(GENERAL) EXHAUST TO PROVIDE ADEQUATE
VENTILATION.
Other Protective Equipment:WEAR INDUSTRIAL WORK CLOTHING. USE RUBBER
APRON OR BOOTS IF NEEDED. HAVE EMERGENCY EYE WASH AND SAFETY SHOWER
AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MIST. DO NOT INGEST. READ PRECAUTIONS ON
LABEL BEFORE USE.
================== Physical/Chemical Properties ==================
HCC:C2
Boiling Pt:B.P. Text:191F,88C
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:0.9890
pH:11.8
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, CLOUDY WHITE OR COLORED LIQUID WITH DISTINCT
AMMONIA ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHLRONIE, BROMINE, IODINE, HYPOCHLORITE, MINERAL ACIDS.
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:TOXIC OXIDES OF NITROGEN AND AMMONIA
GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUE WITH WATER AND FLUSH TO SEWER IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRIORITYPOLLUTNT ACIDS, 712
CAGE:1R664
CAGE:1R664
============= Composition/Information on Ingredients =============
Ingred Name:O-CRESOL (SARA 302/313) (CERCLA)
CAS:95-48-7
RTECS #:GO6300000
Fraction by Wt: <0.1%
OSHA PEL:S, 5 PPM
ACGIH TLV:S, 5 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PHENOL, 2,4,6-TRICHLORO-; (2,4,6-TRICHLOROPHENOL) (SARA
313) (CERCLA)
CAS:88-06-2
RTECS #:SN1675000
Fraction by Wt: <0.1%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:PHENOL, PENTACHLORO-; (PENTACHLOROPHENOL) (SARA 313)
(CERCLA)
CAS:87-86-5
RTECS #:SM6300000
Fraction by Wt: <0.1%
OSHA PEL:S, 0.5 MG/M3
ACGIH TLV:S, 0.5 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:METHANOL; (METHYL ALCOHOL) (SARA 313) (CERCLA)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: >99.7%
OSHA PEL:S, 200 PPM
ACGIH TLV:S, 200 PPM/250 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATES AND DAMAGES ALL
TISSUES. MAY CAUSE LIVER, KIDNEY AND LUNG DAMAGE. MAY CAUSE CARDIAC
ARRYTHMIA, MAY SENSITIZE THE HEART TO EPINEPHRINE. MAY CAUSE
IRRITANT DERMATITIS, ALLERGIC DERMATIT IS OR CHLORACNE. MAY CAUSE
CANCER IN HUMANS (OTHER THAN CORE GROUP COMPOUNDS). INGESTION -
MAJOR HAZARD(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: DUE TO METHANOL. QUANTITIES AS SMALL
AS 1 OZ (30CC) MAY CAUSE PERMANENT BLINDNESS. WILL ALSO CAUSE
ACIDOSIS, ALCOHOL INTOXICATION. IF INGESTED SEEK MED ATTENTION
IMMEDIATELY. SIGNS & SYMPS O F EXPOS: DRY SCALY SKIN, CRACKING &
WEEPING SKIN, COUGH, AND WHEEZING. JAUNDICE, NAUSEA & VOMITING,
UREMIA, ACIDOSIS.
Medical Cond Aggravated by Exposure:DERMATITIS, LIVER DISEASE, KIDNEY
DISEASE, ALCOHOL INTOXICATION.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. BE PREPARED TO DO CPR. INGEST:
GIVE SYRUP OF IPECAC 60CC WITH 180CC OF WATER. EYES: FLUSH EYES
WITH RUNNING WATER FOR AT LEAST 15 MINUTES. SKIN: FLUSH WITH
RUNNING WATER F OR AT LEAST 20 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:59.9F,15.5C
Lower Limits:6.0%
Upper Limits:38.5%
Extinguishing Media:DRY CHEMICAL, CO*2, WATER SPRAY OR
ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY FORM CARBON MONOXIDE, PHOSGENE, AND
CARBONYL BROMIDE WHEN INVOLVED IN FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:DAM UP AND ABSORB. VENTILATE THE AREA. CALL
CLEAN UP TEAM. DO NOT WASH TO DRAIN.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID FREEZING OR ROUGH HANDLING
(BREAKAGE).
Other Precautions:HANDLE WITH CARE! MATERIAL CONTAINS CARCINOGENS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED ORGANIC VAPOR CARTRIDGE, FULL
FACE PIECE, OR NIOSH APPROVED SELF CONTAINED OR NIOSH APPROVED AIR
SUPPLIED RESPIRATOR.
Ventilation:LOCAL & MECHANICAL EXHAUST: USE IN HOOD. SPECIAL: VENTILATE
SPILL.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
LABORATORY COAT, CLOSED SHOES.
Work Hygienic Practices:USE CAREFUL LABORATORY TECHNIQUE. AVOID HAND
CONTACT. MEDICAL MONITORING WITH ANNUAL HISTORY, PHYSICAL & LAB
WORK.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:64.5
Vapor Density:1.11
Spec Gravity:0.792 (WATER=1)
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID. ORGANIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHROMIC ANHYDRIDE, IODINE, ETHANOL, MERCURIC OXIDE, KOH, NAOH,
CHLOROFORM, AND LEAD PERCHLORATE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ERA PRODUCTS IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EMERY DISCS
CAGE:95931
CAGE:95931
============= Composition/Information on Ingredients =============
Ingred Name:SILICON CARBIDE
CAS:409-21-2
RTECS #:VW0450000
Fraction by Wt: 60%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:BACKING (PAPER, FIBRE, CLOTH)
Fraction by Wt: 30%
Ingred Name:BINDER SYSTEM MIXTURE
Fraction by Wt: 10%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: ABSORPTION &
ABRASIONS. INHALATION: COUGHING & SHORTNESS OF BREATH. EARS: MAY
AFFECT HEARING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION. SKIN: ABSORPTION & ABRASIONS.
INHALATION: COUGHING & SHORTNESS OF BREATH. EARS: MAY AFFECT
HEARING.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/PLENTY OF WATER. INHALATION: REMOVE TO
FRESH AIR, APPLY ARTIFICIAL RESPIRATION AS NEEDED. EARS: MOVE FROM
ELEVATED SOUND LEVELS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, FOAM OR WATER
Fire Fighting Procedures:WEAR RESPIRATORY PROTECTION
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL CLEAN UP PROCEDURES
======================Handling and Storage ======================
Other Precautions:DON'T INGEST
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROVED DUST RESPIRATOR
Ventilation:PROVIDE LOCAL/MECHANICAL EXHAUST VENTILATION
Other Protective Equipment:HEARING PROTECTION
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:COATED ABRASIVE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:DUST & RESIN SYSTEM FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:STANDARD LANDFILL METHODS CONSISTENT W/FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:423 OVEN CLEANER
CAGE:0N140
CAGE:0N140
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE, CAUSTIC SODA, LYE
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 5.5%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-BUTOXYETHANOL (ETHYLENEGLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 7.3%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 1.7%
Other REC Limits:200 PPM
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: HEADACHE, NAUSEA, & LOSS
OF CONSCIOUSNESS. SKIN: DRY. INGESTION: HEADACHE, & NAUSEA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, NAUSEA, & LOSS OF
CONSCIOUSNESS. SKIN: DRY. INGESTION: HEADACHE, & NAUSEA.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/WATER. INHALATION: REMOVE TO FRESH AIR.
INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F
Extinguishing Media:CO2, FOAM, OR DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT ON ABSORBENT MATERIAL & CONTAIN FOR
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY AREA.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID INHALATION OR
INGESTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SELF-CONTAINED BREATHING APPARATUS WHEN
>TLV.
Ventilation:LOCAL EXHAUST IF GENERAL IS INADEQUATE. MECHANICAL
(GENERAL): SATISFACTORY.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE. WASH HANDS
BEFORE EATING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1.050
Solubility in Water:COMPLETE
Appearance and Odor:VIOLET LIQUID W/CITRUS ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CO & CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:ANY METHOD FOR DISPOSAL OF CHEMICAL WASTE
SUBJECT TO FEDERAL, STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RITODRINE HYDROCHLORIDE
CAGE:GO395
CAGE:GO395
CAGE:60567
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:RITODRINE HYDROCHLORIDE*95-1*
CAS:23239-51-2
RTECS #:DO6524000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE/SKIN/RESPIRATORY TRACT
IRRITATION & HYPERSENSITIZATION. MAY BE ABSORBED THROUGH THE SKIN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MAY CAUSE EYE/SKIN/RESPIRATORY TRACT
IRRITATION. MAY BE ABSORBED THROUGH THE SKIN.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. INGESTION: FLUSH MOUTH OUT
W/WATER. SKIN/EYES: FLUSH W/WATER. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2, FOAM AS APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RECOMMENDED PERSONAL PROTECTIVE
EQUIPMENT. VACUUM W/A VACUUM CLEANER HAVING A HIGH EFFICIENCY
PARTICULATE FILTER/ABSORB LIQUID W/PAPER TOWELS. WIPE WORKING
SURFACES TO DRYNESS, THEN WASH W/SOAP & WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T USE IF DISCOLORED/CONTAINS A
PRECIPITATE.
Other Precautions:WHEN HANDLING PHARMACEUTICAL PRODUCTS, AVOID ALL
CONTACT & INHALATION OF DUST/FUMES/MISTS/VAPORS ASSOCIATED
W/PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:DISPOSABLE PROTECTIVE APPAREL
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
PH: 4.8-5.5.
================== Physical/Chemical Properties ==================
pH:(SUPP)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS SOLUTION W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:DISCOLORATION, CONTAINS A PRECIPITATE.
Hazardous Decomposition Products:TOXIC FUMES WHEN HEATED TO
DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AB-538
Preparer's Name:CLARK HERREN
CAGE:0MB12
CAGE:0MB12
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOHEXYLAMINE (SARA III)
CAS:108-91-8
RTECS #:GX0700000
Fraction by Wt: 60%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM; 9394
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL-RAT LD50=600 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION- MAY CAUSE IRRITATION OF
RESPIRATORY TRACT.EYES- WILL CAUSE SEVERE IRRITATION. SKIN- MAY
CAUSE IRRITATION OR CHEMICAL BURNS UPON PROLONGED CONTACT.
INGESTION- MODERATELY TOXIC.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN:
REMOV E CONTAMINATED CLOTHING. WASH WITH SOAPAND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:293C
Extinguishing Media:WATER FOG, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL,ELIMINATE IGNITION SOURCES.
PREVENT SPILL FROM ENTERING GROUND OR SURFACE WATERS. COLLECT OR
ABSORB AND STORE SEPARATELY IN CLOSED CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED LEAKPROOF STAINLESS OR
CARBON STEEL CONTAINERS. SEGREGATE FROM ACIDS & OXIDIZERS. STORE
AWAY FROM IGNITION SOURCES.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MASK SUITABLE FOR ORGANIC VAPORS, OR USE SELF
CONTAINED BREATHING APPARATUS.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER,WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
================== Physical/Chemical Properties ==================
HCC:B2
Boiling Pt:B.P. Text:200F,93C
Vapor Pres:25
Vapor Density:1
Spec Gravity:1.0
Evaporation Rate & Reference:1.1
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, AMMONIA ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS,OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VACUFILM
CAGE:33339
CAGE:33339
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL (ETHANOL) -DENATURED
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 92%
Other REC Limits:1900 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:YES
Health Hazards Acute and Chronic:EYE:MAY CAUSE MILD IRRITATION.
SKIN:MAY CAUSE MILD IRRITATION. INHALAED:MAY CAUSE IRRITATION OF
THE THROAT. INGESTED:MAY BE POISONOUS.
Explanation of Carcinogenicity:MFR LISTS YES TO OSHA BUT HMIS CANNOT
FIND A CARCINOGEN REFERENCE FROM OSHA.
Effects of Overexposure:EYE:MAY CAUSE MILD IRRITATION. SKIN:MAY CAUSE
MILD IRRITATION. INHALAED:MAY CAUSE IRRITATION OF THE THROAT.
INGESTED:MAY BE POISONOUS.
Medical Cond Aggravated by Exposure:NO INFORMATION GIVEN BY MFR ON
MSDS.
======================= First Aid Measures =======================
First Aid:EYES:IRRIGATE IMMEDIATELY AND THOROUGHLY WASH WITH WATER FOR
AT LEAST 15 MINS. GET MEDICAL ATTENTION IF ANY SYMPTOMS PERSIST
AFTER WASHING. SKIN: WASH WITH SOAP & WATER. INHALED:REMOVE TO
FRESH AIR. I NGESTED:DO NOT GIVE LIQUIDS IF VICTIM IS UNCONSCIOUS.
CONTACT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:46.0F,7.8C
Lower Limits:4.3
Upper Limits:19
Extinguishing Media:ALCOHOL FOAM, DRY CHEMICAL, CO2, WATER SPRAY
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. SMALL SPILLS
MAY BE COLLECTED WITH ABSORBENT MATERIAL AND TRANSFERRED TO A
SUITABLE CONTAINER FOR DISPOSAL.
Neutralizing Agent:NO INFORMATION GIVEN BY MFR ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND OPEN
FLAME. KEEP CONTAINER CLOSED. USE WITH ADEQUATE VENTILATION. KEEP
IN A COOL, DRY PLACE.
Other Precautions:USE ACCORDING TO DIRECTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED
Ventilation:USE LOCAL EXHAUST TO KEEP EXPOSURE UNDER 1000 PPM.
Other Protective Equipment:NONE
Work Hygienic Practices:MFR: ?HMIS:USE GOOD CHEMICAL HYGIENE
PRACTICE. AVOID ALL UNNECESSARY EXPOSURE. WASH THOROUGHLY BEFORE
EATING OR DRINKI
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:F3
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:165F,74C
Vapor Pres:100 MM
Vapor Density:1.59
Spec Gravity:0.79
Evaporation Rate & Reference:1.9 (N-BUAC=1)
Solubility in Water:SOLUBLE
Appearance and Odor:A CLEAR, PINK LIQUID WITH A FRAGRANT, FRUITY ODOR.
Corrosion Rate:UNKNOWNN
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS CAN CAUSE A REACTION.
Stability Condition to Avoid:HEAT AND IGNITION SOURCES
Hazardous Decomposition Products:COMBUSTION WILL PRODUCT CARBON DIOXIDE
AND SOMETIMES CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE LIQUID IN PROPER EQUIPMENT. DISPOSE
OF IN ACCORDANCE WITH LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:823-7828 WORKING SOLUTION 25 GALS
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 90-95%
Ingred Name:STABILIZING AGENT
Fraction by Wt: 5-10%
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 1-5%
Ingred Name:ACETIC ACID (ETHYLENEDIAMINETETRAACETIC ACID), EDTA
CAS:60-00-4
RTECS #:AH4025000
Fraction by Wt: <1%
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS *95-3*
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: <1%
Other REC Limits:200 PPM
OSHA PEL:260 MG/CUM
ACGIH TLV:262 MG/CUM (SKIN)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1,2-PROPANEDOIL, 3-MERCAPTO- (1-THIOGLYCEROL)
*95-3*
CAS:96-27-5
RTECS #:TY8140000
Fraction by Wt: <1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE ALLERGIC SKIN REACTION.
CONTACT W/ACID, BASE LIBERATES HARMFUL GAS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN REACTION
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, REMOVE TO FRESH AIR. EYES: WASH
OUT IMMEDIATELY W/WATER. SKIN: IMMEDIATELY WASH W/SOAP & WATER.
INGESTION: DRINK 1-2 GLASSES OF WATER. NEVER GIVE ANYTHING BY MOUTH
TO AN UN CONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
FIRE/EXCESSIVE HEAT MAY PRODUCE HAZARDOUS DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER W/LARGE AMOUNTS OF WATER.
OTHERWISE, ABSORB W/VERMICULITE/OTHER INERT MATERIAL, THEN PLACE IN
A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO REMOVE
RESIDUAL CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:USE W/ADEQUATE VENTILATION. KEEP
CONTAINERS TIGHTLY CLOSED. KEEP AWAY FROM INCOMPATIBLE SUBSTANCES.
Other Precautions:AVOID CONTACT W/EYES, SKIN & CLOTHING. KEEP OUT OF
REACH OF CHILDREN. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUE,
FOLLOW LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTIED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. IF FORMALDEHYDE IS EMITTED, USE
FULL FACEPIECE W/CARTRIDGES/CANISTERS SPECIFICALLY APPROVED BY
NIOSH FOR PROTECTION/USE TYPE C AIR-SUPPLIED RESPIRATOR.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER
HOUR). VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. (SUPP)
Other Protective Equipment:RECOMMENDED DECONTAMINATION FACILITIES: EYE
BATH, SAFETY SHOWER, WASHING FACILITIES.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
VENTILATION CONT'D: SUPPLEMENTARY LOCAL EXHAUST VENTILATION, CLOSED
SYSTEMS/RESPIRATORY PROTECTION MAY BE NEEDED IN SPECIAL
CIRCUMSTANCES. PERCENT VOLATILE VOLUME IS FOR WEIGHT. PH: 6.2-6.8.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Vapor Pres:24
Vapor Density:0.6
Spec Gravity:1.22
pH:(SUPP)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS, ODORLESS LIQUID
Percent Volatiles by Volume:90-95
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG BASES.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:FORMALDEHYDE, SULFUR DIOXIDE, CO2, CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT/DISPOSAL MAY BE SUBJECT TO
NATIONAL, STATE/LOCAL LAWS. FLUSH TO SEWER W/LARGE AMOUNTS OF
WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:C-5A ANTISEIZE, ANTI-SEIZE LUBRICANT ( FORMERLY ON-N-OFF )
Preparer's Name:CATHY GRIFFITH
CAGE:05VH4
CAGE:05VH4
============= Composition/Information on Ingredients =============
Ingred Name:GRAPHITE
CAS:7782-42-5
RTECS #:MD9659600
Fraction by Wt: 20%
OSHA PEL:2.0 MG/M3
ACGIH TLV:2.5 MG/M3
Ingred Name:DISTILLATES (PETROLEUM), HYDROTREATED HEAVY NAPHTHENIC
CAS:64742-52-5
RTECS #:PY8035000
Fraction by Wt: 25%
Ingred Name:ALLBRI NATURAL COPPER
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 25%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PETROLEUM DISTILLATE
CAS:64742-18-3
Fraction by Wt: 15%
OSHA PEL:5 MG/M3
OSHA STEL:10 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:SILICON DIOXIDE ( ENCAPSULATED )
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0.2%
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED.AT ELEVATED
TEMPERATURES MAY CAUSE IRRITATION OF THE EYES AND REPIRATORY TRACT.
ACUTE EFFECTS: EYE CONTACT: SLIGHTLY IRRITATING BUT DOES NOT
INJURE EYE TISSUE.ACUTE EFFECTS SKIN CONTACT: PROLONGED OR
REPEATED SKIN CONTACT MAY CAUSE IRRITATION. ACUTE EFFECTS
INHALATION: INHALATION OF DUST AT LEVELS ABOVE RECOMMENDED
EXPOSURE LIMITS MAY CAUSE METALLIC OR SWEET TASTE, IR RITATION OF
PHARYNX, AND POSSIBLE UNCERATION WITH PERFORATION OF THE NASAL
SEPTUM. ACUTE EFFECTS INGESTION: MODERATELY TOXIC. IRRITATING TO
MOUTH, THROAT AND STOMACH, WITH NAUSEA.
Effects of Overexposure:REPEATED AND PROLONGED INHALATION OF GRAPHITE
OR CARBON DUSTS MAY CAUSE PULMONARY FIBROSIS, EMPHYSEMA, AND
PNEUMOCONIOSIS. THE SEVERITY OF THESE EFFECTS IS GREATLY
INFLUENCED BY THE PRESENCE OF OTHER HARMFUL MINERAL DUSTS, MOST
NOTABLY CRYSTALLINE SILICA. *
Medical Cond Aggravated by Exposure:PREEXISTING PULMONARY AND
DERMATOLOGICAL DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO HAZARDOUS
COMPONENTS.
======================= First Aid Measures =======================
First Aid:EYES IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER. GET
MEDICAL ATTENTION, IF IRRITATION PERSISTS.SKIN: WASH WITH SOAP
AND WATER.GET MEDICAL ATTENTION IF IRRITATION DEVELOPS OR
PERSISTS. INHALATI ON: NO SPECIFIC TREATMENT IS NECESSARYSINCE
THIS MATERIAL IS NOT LIKELY TO BE HAZARDOUS BY INHALATION.IF
EXPOSED TO EXCESSIVE LEVELS OF DUSTS OR FUMES, REMOVE TO FRESH AIR
AND GET MEDICAL ATTENTION IF COUGH OR OTHER SYMPTOMS DEVELOP.
INGESTION:IF SWALLOWED, DO NOT INDUCE VOMITING. GIVE VICTIM A
GLASS OF WATER OR MILK. CALL A PHYSICIAN OR POISON CONTROL CENTER
IMMEDIATELY. NEVER GIVE ANYTH ING BY MOUTH TO AN UNCOSCIOUS
PERSON.
===================== Fire Fighting Measures =====================
Flash Point:=148.9C, 300.F
300F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM,WATER FOG.
Fire Fighting Procedures:FINELY DIVIDED DUST IN AIR MAY PRESENT
EXPLOSION HAZARD. PREVENT DUST BUILDUP. CLOSED CONTAINERS MAY
RUPTURE OR EXPLODE ( DUE TO PRESSURE BUILD-UP) WHEN EXPOSED TO
EXTREME HEAT. IRRITATING AND/OR TOXIC GASES OR FUMES MAY BE
GENERATED BY THERMAL DECOMPOSITION OR COMBUSTION.
Unusual Fire/Explosion Hazard:USE NIOSH-APPROVED SELF-CONTAINED
BREATHING APPARTUS AND FULL PROTECTIVE CLOTHING. USE WATER TO COOL
EXPOSED CONTAINERS. WATER STREAM DIRECTED INTO FIRE MAY CAUSE
FROTHING WITH SUBSEQUENT SPREAD OFFLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:RECLAIM CLEAN MATERIAL. CONTAINATED MATERIAL
SHOULD BE SWEPT OR SHOVELED INTO APPROPRIATE WASTE CONTAINER AND
DISPOSED OF IN ACCORDANCE WITH APPLICABLE FEDERAL, STATE AND LOCAL
REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:WASH HANDS BEFORE EATING. AVOID
PROLONGED OR REPEATED CONTACT WITH SKIN. DO NOT TAKE INTERNALLY.
FOR INDUSTRIAL USE ONLY. STORAGE:STORE AWAY FROM HEAT. KEEP OUT
OF THE REACH OF CHILDERN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED UNDER GENERAL
VENTILATION. IF EXPOSURE LEVELS ARE UNKNOWN, IF LEVELS EXCEED
TLV/PEL, OR IF EFFECTS OCCUR, USE NIOSH-APPROVED DUST/MIST
RESPIRATOR IN ACCORDANCE WITH APPLICABLE HEALTH AND SAFETY
REGULATIONS AND MANUFACTURER'S RECOMMEDATIONS.
Ventilation:GENERAL VENTILATION USUALLY ADEQUATE.
Other Protective Equipment:ACCESSIBLE EYE WASH AND SAFETY SHOWER.
Work Hygienic Practices:FOLLOW GENERAL INDUSTRUAL SAFETY PRACTICES
DURING USE. DO NOT REUSE EMPTY CONTAINERS WITHOUT COMMERCIAL CLEAN
OR RECONDITION. FOLLOW ALL MSDS/LABEL PRECAUTIONS EVEN AFTER
CONTAINR IS EMPTIED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:>287.8C, 550.F
B.P. Text:550-4215 F
Vapor Density:>1
Spec Gravity:1.3017
pH:0.0%
Viscosity:HIGH
Evaporation Rate & Reference:SLOWER
Solubility in Water:INSOLUBLE
Appearance and Odor:COPPER COLORED, SLIGHT PETROLEUM
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG LEWIS OR MINERAL ACIDS.STRONG BASES OR OXIDANTS. NITRATES,
NITRITES, CHLORINATED HYDROCARBONS, CHLORIDES, PALLADIUM,
SELENIUM, MANGANESE + POTASSIUM CHLORATE, SODIUM CARBONATE,
SUFATES, DIBORANE.
Stability Condition to Avoid:PROLONGED EXPOSURE TO HEAT.
Hazardous Decomposition Products:OXIDES OF CARBON. VARIOUS
HYDROCARBONS. HAZARDOUS POLYMERIZATION: WILL NOT OCCUR UNDER
NORMAL CONDITIONS.
=================== Toxicological Information===================
Toxicological Information:** INHALATION OF FREE RESPIRABLE SILICA MAY
CAUSE SILICOSIS OR OTHER SERIOUS DELAYED LUNG INJURY. SILICA MAY
BE RELEASED BY GRINDING OR MACHINING OF COATED MATERIALS. USE
NIOSH-APPROVED DUST/MIST R ESPIRATOR WHEN GRINDING OR MACHINING
COATING OR COATED ITEMS. EFFECTS OF OVEREXPOSURE - ***
===================== Ecological Information =====================
Ecological:***CHRONIC HAZARDS:THIS PRODUCT CONTAINS ENCAPSULATED
METAL POWDER WHICH CONTAINS COPPER AND ZINC. NO EXPOSURE TO FREE
METAL POWDER IS ANTICIPATED DURING NORMAL APPLICATION OF THIS
PRODUCT. METAL POWDER MAY BE RELEASED, HOWEVER, BY GRINDING OR
MACHINING OF CURED COMPOUND OR COATED SURFACE. REPEATED OR
PROLONGED OVEREXPOSURE TO METAL DUST MAY CAUSE METAL-FUME FEVER,
METALLIC TASTE, AND DISCOLO RATION OF THE SKIN AND HAIR. REFER TO
PROTECTIVE EQUIPMENT SECTION FOR APPROPRIATE PROTECTIVE MEASURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:REVIEW ALL CURRENT FEDERAL, STATE, AND LOCAL
REGULATIONS REGARDING HEALTH AND DISPOSAL FOR APPROPRIATE DISPOSAL
PROCEDURES. INCINERATION PREFERRED.
=================== MSDS Transport Information ===================
Transport Information:OSHA: HAZARDOUS BY DEFINITION OF HAZARD
COMMUNICATION STANDARD (29 CFR 1910.1200 )CERCLA - SARA HAZARD
CATERGORY:THIS PRODUCT HAS BEEN HAS BEEN REVIEWED AND IS
CONSIDERED, UNDER APPLICABLE DEFINI TIONS, TO MEET THE FOLLOWING
CATEGORIES: IMMEDIATE HEALTH HAZARD CHRONIC HEALTH HAZARD. SARA
SECTION 313: THIS PRODUCT CONTAINS THE FOLLOWING CATEGORIES:
IMMEDIATE HEALTH HAZARD CHRONIC HEALTH HAZA RD SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE
REPORTING REQUIREMENTS OF SECTION 313 AND 40 CFR PART 372:****
===================== Regulatory Information =====================
SARA Title III Information:****CHEMICAL NAME COPPER CAS NUMBER
4770-50-8 LESS THAN 25.0%.TOXIC SUBSTANCES CONTROL ACT: THE
CHEMICAL SUBSTANCES IN THIS PRODUCT ARE ON THE TSCA SECTION 8
INVENTORY.THIS PRODUST CONTAINS THE FOLLOWING CHEMICAL
SUBSTANCES SUBJECT TOTHE REPORTING REQUIREMENTS OF TSCA 12 (B) IF
EXPORTED FROM THE UNITED STATES: NONE NEW JERSEY RIGHT-TO-KNOW:
THE FOLLOWING MATERIALS ARE NON-HAZARDOUS, BUT AR E AMONG THE TOP
FIVE COMPONENTS IN THIS PRODUCT: FATTY ACIDS, TALLOW, CALCIUM
SALTS CAS NUMBER:64755-01-7 *****
State Regulatory Information:*****PENNSYLVANIA RIGHT-TO-KNOW: THE
FOLLOWING NON-HAZARDOUS INGREDIENTS ARE PRESENT IN THE PRODUCT AT
GREATER THAN 3%: CHEMICAL NAME: FATTY ACIDS, TALLOW, CALCIUM
SALTS CAS NUMBER 64755-01-7 HAYDR OTREATED HEAVY PARAFFINIC DIST
64742-54-7CALIFORNIA PROPOSITION 65: WARNING: THE CHEMICAL (S)
NOTED BELOW AND CONTAINED IN THIS PRODUCT, ARE KNOWN TO THE STATE
OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFETS OR OTHER REPRODUCTIVE
HARM: NONE KNOWN VOC CONTENT: =<0.5 LBS/GAL; G/L ( CALCULATED)
CANA DIAN WHMIS: THIS MSDS HAS BEEN PREPARED IN COMPLIANCE WITH
CONTROLLED PRODUCT REGULATIONS EXCEPT FOR USE OF THE 16 HEADINGS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CAUSTIC SODA, LYE, SODIUM HYDRATE, 6466
CAGE:DO242
CAGE:63612
CAGE:DO242
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (CERCLA)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 100%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM COMPOUND; (NAOH.H*2O)
CAS:12200-64-5
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXTREMELY TOXIC AND CORROSIVE. CAUSES
SEVERE BURNS ON CONTACT WITH ANY BODY TISSUE. VAPOR IRRITATING TO
EYES AND RESPIRATORY PASSAGES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:DATA NOT AVAILABLE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:
IMMEDIATELY FLUSH THOROUGHLY W/LARGE AMOUNTS OF WATER. EYES:
IMMEDIATELY FLUSH THOROUGHLY W/WATER FOR AT LEAST 15 MIN. INHAL:
REMOVE TO FRES H AIR; GIVE ARTIFICIAL RESPIRATION IF BREATHING HAS
STOPPED. INGEST: DO NOT INDUCE VOMITING; IF CONSCIOUS, GIVE WATER
FREELY & GET MEDICAL ATTENTION. REMOVE CONTAMINATED CLOTHING & WASH
BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:FLOOD WITH WATER, USING CARE NOT TO SPLATTER OR
SPLASH THE MATERIAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CAN REACT WITH CERTAIN METALS (AL, SN,
MG, CU, ETC) TO RELEASE EXPLOSIVE HYDROGEN GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA OF ALL UNNEC PERS. WEAR SUITABLE
PROT EQUIP AS LISTED. ELIM ANY IGNIT SOURCES UNTIL AREA IS DETERMD
FREE FROM EXPLO OR FIRE HAZS. CNTN RELS & ELIM ITS SOURCE IF THIS
CAN BE DONE W/OUT RI SK. TAKE UP & CONTAINERIZE FOR PROPER (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR TIGHTLY CLOSED. STORE IN A
DRY, WELL-VENTILATED AREA AWAY FROM ACIDS, METALS, EXPLOSIVES,
ORGANIC PEROXIDES & EASILY IGNITABLE MATERIALS.
Other Precautions:DO NOT BREATHE DUST OR VAPOR. WHILE MAKING SOLUTION
ADD SLOWLY TO SURFACE OF SOLUTION TO AVOID VIOLENT SPLATTERING. DO
NOT GET IN EYES, ON SKIN OR ON CLOTHING. RETAINED RESIDUE MAY MAKE
EMPTY CONTAINE RS HAZARDOUS; USE CAUTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKPLACE EXPOS LIM(S) OF PROD OR ANY
COMPONENT IS EXCEEDED (SEE TLV/PEL), A NIOSH APPRVD AIR SUPPLIED
RESP IS ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL CTL. OSHA REGS
ALSO PERMIT OTHER NIOSH APPR VD RESPS (NEG PRESS TYPE) UNDER
(SUPDAT)
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
PROTECTIVE CLOTHING (IMPERVIOUS) SHOULD BE WORN WHEN HANDLING THIS
MATL.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL PROC: DISP AS DESCRIBED. COMPLY W/FED, STATE & LOCAL REGS ON
REPORTING RELS. REFER TO REGULATORY INFO FOR REPORTABLE QTY & OTHER
REGULATORY DATA. RESP PROT: SPECIFIED CNDTNS (SEE SFTY EQUIP SUPP
LIER). ENGINEERING &/OR ADMIN CTLS SHOULD BE IMPLEMENTED TO REDUCE
EXPOS. EYE PROT: & FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:2534F,1390C
Melt/Freeze Pt:M.P/F.P Text:605F,318C
Spec Gravity:2.13 (H*2O=1)
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE, ODORLESS, DELIQUESCENT PELLETS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ACIDS, CHLORINATED HYDROCARBONS, METALS, ORGANIC MATERIALS.
Stability Condition to Avoid:CONTACT WITH MOISTURE MAY GENERATE
SUFFICIENT HEAT TO IGNITE SURROUNDING COMBUSTIBLE MATERIAL.
Hazardous Decomposition Products:NONE INDICATED.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATL DOES NOT HAVE AN EPA WASTE NUMBER & IS NOT
A LISTED WASTE, HOWEVER CONSULTATION W/PERMITTED WASTE DISP SITE
(TSD) SHOULD BE ACCOMPLISHED. ALWAYS CNTCT A PERMITTED WASTE
DISPOSER (TSD) TO ASSURE C OMPLIANCE W/ALL CURRENT LOCAL, STATE &
FED REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DOLPHON CC-1089-A
Kit Part:Y
CAGE:DO943
CAGE:81476
CAGE:DO943
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN
===================== Hazards Identification =====================
Effects of Overexposure:SKIN/EYE:MILD IRRITANT;SKIN SENSITIZER.ACUTE
ORAL LD50 (RATS)=13.3G/KG.
======================= First Aid Measures =======================
First Aid:SKIN:WASH W/SOAP & WATER. EYES:FLUSH WITH PLENTY OF WATER.
===================== Fire Fighting Measures =====================
Flash Point:454 F TCC
Extinguishing Media:CO*2,DRY CHEM.,FOAM
================== Accidental Release Measures ==================
Spill Release Procedures:BRUSH OR WORK PENETONE SRN OR BUTYL CARBITOL
INTO THE SPILLED RESIN & FLUSH WITH WATER.FOR SMALL SPILLS,ACETONE
CAN BE USED.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID SKIN & EYE CONTACT.WASH WELL
WITH WATER.
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
KEY1:N1.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>626 F
Spec Gravity:1.165
Evaporation Rate & Reference:NONE
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR,AMBER LIQUID
Percent Volatiles by Volume:0.3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO,CO*2,ALDEHYDES & OTHER ORGANICS.
==================== Disposal Considerations ====================
Waste Disposal Methods:LAND FILL IN METAL CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:9192699
CAGE:13483
CAGE:13483
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER,(SUP DATA
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS NEEDED
INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:V1
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRE-GENERALLY HIGH
TEMPERATURE INCINERATION ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CAI-400 SERIES
CAGE:0VMB9
CAGE:0VMB9
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (KNOWN CARCINOGEN BY NTP;
IARC CARC - GROUP 3) *96-2*
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 0-10%
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON *96-2*
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 0-5%
Ingred Name:COPPER (DUST & MIST), BRONZE POWDER *96-2*
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0-35%
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MOLYBDENUM (SOLUBLE COMPOUND)
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 0-25%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:COBALT (ANIMAL CARCINOGEN BY IARC - GROUP 2B) *96-2*
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 0-20%
Other REC Limits:0.05 PPM
OSHA PEL:0.1 MG/CUM
ACGIH TLV:0.05 MG/CUM
Ingred Name:TIN *96-2*
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 0-5%
OSHA PEL:2 MG/CUM
ACGIH TLV:2.0 MG/CUM
Ingred Name:TUNGSTEN (INSOLUBLE), WOLFRAM *96-2*
CAS:7440-33-7
RTECS #:YO7175000
Fraction by Wt: 0-5%
ACGIH TLV:5 MG/CUM
Ingred Name:COLUMBIUM, NIOBIUM *96-2*
CAS:7440-03-1
Fraction by Wt: 0-5%
Other REC Limits:5 MG/CUM
Ingred Name:TANTALUM
CAS:7440-25-7
RTECS #:WW5505000
Fraction by Wt: 0-5%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:TITANIUM, DRY POWD *96-2*
CAS:7440-32-6
RTECS #:XR1700000
Fraction by Wt: 0-3%
Ingred Name:MANGANESE *96-2*
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 0-1%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM (DUST)
Ingred Name:PALLADIUM *96-2*
CAS:7440-05-3
Fraction by Wt: 0-36%
Ingred Name:ALUMINUM OXIDE, BAUXITE, ALUMINA, DIALUMINUM TRIOXIDE
*96-2*
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 1-5%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:TRADE SECRET COMPONENT
Fraction by Wt: 2.5%
Ingred Name:NICKEL (SUSPECTED ANIMAL/HUMAN CARCINOGEN BY IARC GROUP 2B,
SUSPECTED CARCINOGEN BY NTP) *96-2*
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 40-100%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 0-5%
ACGIH TLV:10 MG/CUM
Ingred Name:BORON *96-2*
CAS:7440-42-8
RTECS #:ED7350000
Fraction by Wt: 0-5%
Ingred Name:ALUMINUM*96-2*
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 0-3%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:NICKEL-INHALATION: MAY AFFECT THE
LUNGS, PARANASAL SINUS, CENTRAL NERVOUS SYSTEM. MAY CAUSE LUNG
CANCER, SINUS & PULMONARY CARCINOGENESIS DUE TO CHRONIC EXPOSURE.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:NICKEL-HEADACHE, VERTIGO, NAUSEA, VOMITING,
EPIGASTRIC PAIN, SUBSTERNAL PAIN, COUGH, HYPERPNEA, CYANOSIS,
WEAKNESS, LEUKOCYTOSIS, PNEUMONITYS, DELIRIUM, CONVULSIONS
======================= First Aid Measures =======================
First Aid:EYES: IRRIGATE IMMEDIATELY W/LARGE AMOUNTS OF WATER. SKIN:
IMMEDIATELY FLUSH W/SOAP & WATER. INHALATION: MOVE EXPOSED PERSON
TO FRESH AIR AT ONCE. IF BREATHING HAS STOPPED, PERFORM CPR. KEEP
WARM & AT REST. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:DRY CHEMICAL, SAND, WATER
Fire Fighting Procedures:FLOOD W/WATER FROM A DISTANCE.
Unusual Fire/Explosion Hazard:FINELY DIVIDED DUST MAY IGNITE WHEN IN
CONTACT W/A FLAME. POSSIBLE UNBURNED VAPORS, ALUMINUM IS CLASSIFIED
AS A FLAMMABLE SOLID.
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROVED RESPIRATORY EQUIPMENT, PROTECTIVE
MATERIAL BY DRY SWEEPING. SALVAGE MATERIAL FOR ON-SITE
REUSE/RECYCLING.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PRODUCT DRY & IN CLOSED
CONTAINERS. DON'T STORE NEAR MINERAL ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED PARTICULATE RESPIRATORS
WHENEVER DUST MAY BE DETECTED INTO THE AIR.
Ventilation:ADEQUATE LOCAL EXHAUST VENTILATION SYSTEM TO MAINTAIN
AIRBORNE CONCENTRATIONS <OEL.
Other Protective Equipment:SAFETY SHOWERS, EYE WASH STATIONS
BEFORE REUSE. WASH HANDS THOROUGHLY AFTER HANDLING. KEEP WORK AREA
CLEAN.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:GRAY SOLID W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, SULFUR, SELENIUM, WOOD & OTHER COMBUSTIBLES, NICKEL
NITRATE, STRONG OXIDIZERS, HYDROGEN PEROXIDE, ALKALIES
Stability Condition to Avoid:ELEVATED & EXTREME TEMPS, FLAME
Hazardous Decomposition Products:BY PLASMA FLAME: OZONE & NITRIC OXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:REPRODOT DEV/REPL CONCENTRATE
CAGE:61263
CAGE:61263
============= Composition/Information on Ingredients =============
Ingred Name:HYDROQUINONE. LD50:(ORAL,RAT)320 MG/KG
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 5%
OSHA PEL:2 PPM
ACGIH TLV:2 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SODIUM HYDROXIDE
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 5%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POTASSIUM CARBONATE (2:1); (POTASSIUM HYDROXIDE).
LD50:(ORAL,RAT)1870 MG/KG
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 5%
OSHA PEL:2 PPM, C
ACGIH TLV:2 PPM, C
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT NAME
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TREAT AS STRONG CAUSTIC. CONTAINS
HYDROQUINONE & ALKALI.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:WARNING! CAUSES EYE BURNS. MAY CAUSE SKIN
IRRITATION & ALLERGIC SKIN REACTION.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:SKIN: WASH EXPOSED AREA THOROUGHLY WITH SOAP AND WATER. EYES:
FLUSH WITH WATER FOR AT LEAST 15 MIN. INGEST: GIVE A GLASS OF WATER
& CALL PHYSICIAN. INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE
O2/A RTF RESP) .
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER MIST, ALCOHOL FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
DO NOT BREATHE COMBUSTION FUMES. TAKE SUITABLE PREC (MASK, AIR IF
PACKED) IF INVOLVED W/PROD FIRE.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL AND NEUTRALIZE WITH SODIUM
BISULFITE OR CAUSTIC. ABSORB WITH MATERIALS SUCH AS VERMICULITE OR
FLUSH TO CHEMICAL SEWER OR WATER TREATMENT IF PERMITTED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED IN COOL,
DRY PLACE WHEN NOT IN USE. KEEP FROM FREEZING.
Other Precautions:WASH HANDS AFTER USE, BEFORE EATING, USING WASHROOM
OR SMOKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:MECHANICAL RECOMMENDED.
Other Protective Equipment:CHEMICAL APRON. EMERG EYE WASH STATION AND
DELUGE SHOWER
Work Hygienic Practices:WASH HANDS AFTER USING OR CONTACT.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:C2
Boiling Pt:B.P. Text:221F,105C
Melt/Freeze Pt:M.P/F.P Text:SOLUTION
Spec Gravity:1.23(H2O=1)
pH:11.8
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID, SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT MIX WITH ACIDS.
Stability Condition to Avoid:DO NOT FREEZE.
Hazardous Decomposition Products:SOX, NO3.
==================== Disposal Considerations ====================
Waste Disposal Methods:NEUTRALIZE AND FLUSH TO CHEMICAL SEWER OR WATER
TREATMENT WITH PLENTY OF WATER, IF PERMITTED. DISPOSE OF IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LE PAGES 648
CAGE:08874
CAGE:08874
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 50%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ACETATE (SARA III)
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: <5%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5%
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:TEXTILE SPIRITS
Fraction by Wt: 25%
ACGIH TLV:500PPM (MFR)
===================== Hazards Identification =====================
Effects of Overexposure:INHAL: IRRIT TO EYES,NOSE,THROAT.
HDCH,DIZZ,NAUS,WEAKNESS,LOSS OF CONSCIOUSNESS. EYE: BURNS/IRRIT
======================= First Aid Measures =======================
First Aid:INHAL: PROVIDE FRESH AIR. GIVE ARTIF RESP OR OXYGEN IF NEC.
CALL DOCTOR. EYE: LUBRICATE W/ CP CAST OR OIL OR WASH W/ LARGE
AMOUNTS OF WATER FOR 15 MIN. CALL DOCTOR
===================== Fire Fighting Measures =====================
Flash Point:-7-0F.
Lower Limits:1.1
Extinguishing Media:CO*2,DRY CHEM,FOAM,WATER MAY BE INEFFECTIVE
Fire Fighting Procedures:WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. VENT AREA. AVOID
BREATHING VAPORS. REMOVE W/ INERT ABSORBENT & NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN CLOSED CONTAINERS. AVOID
SPARKS OR FLAME WHEN HANDLING. CAN BE STORED UNDER AMBIENT
CONDITIONS. AVOID PROLONGED SKIN CONTACT.
Other Precautions:AVOID PROLONGED CONTACT W/ SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD MASK W/ CHEM CANISTER OR
SUPPLIED AIR (MFR)
Ventilation:GENERAL/LOCAL TO KEEP TLV BELOW TLV OF 150PPM
Supplemental Safety and Health
CONTAINER: 30 CC. TUBE. INGRED: ALLYL MUSTARD OIL <1%.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:133-260F
Vapor Pres:190
Vapor Density:>1
Spec Gravity:0.8652
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECOMMENDS INCINERATION. SOLID RESIDUE TO
SANITARY LANDFILL. DO NOT INCINERATE CLOSED CONTAINERS. DISPOSAL
METHODS MUST BE IAW FED, STATE & LOCAL CODES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-L-19538 (36440 GRAY) 1565GY10
Preparer's Name:C. A. HOPE
CAGE:00297
CAGE:00297
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 35-40%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5-10%
Other REC Limits:NOT SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DI-SEC-OCTYL PHTHALATE (DI-2-ETHYLHEXYL-PHTHALATE)(SARA
III)
CAS:117-81-7
RTECS #:TI0350000
Fraction by Wt: 1-5%
Other REC Limits:NIOSH: REDUCE EXPO*
OSHA PEL:5 MG/M3/10 STEL
ACGIH TLV:5 MG/M3; 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10-15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 1-5%
Other REC Limits:NOT SPECIFIED
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:ISOBUTYL ACETATE (SARA III)
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM
ACGIH TLV:150 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SILICA, AMORPHOUS, DIATOMACEOUS EARTH, CONTAINING LESS THAN
1% CRYSTALLINE SILICA
CAS:61790-53-2
RTECS #:HL8600000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:20 MPPCF
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <0.2%
Other REC Limits:NOT SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:VOC: 5.1 LBS/GAL
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION. SKIN: PROLONG &/OR
REPEAT CONTACT-DEFATTING. ABSORPTION: SYSTEMIC EFFECTS. INHALE OF
HIGH CONCENTRATIONS MAY CAUSE RESPIRATORY TRACT IRRITATION &
CENTRAL NERVE SYSTEM DEPRESSION. REPE AT/PROLONG INHALE OF HIGH
CONC OF PARTICULATES: LUNG CHANGES. INGESTION: GASTROINTESTINAL
DISTURBANCES. LUNG ASPIRATION.
Explanation of Carcinogenicity:CRYSTALLINE SILICA AND DI(2-ETHYL HEXYL)
PHTHALATE LISTED AS CARINOGEN.
Effects of Overexposure:SKIN: REDNESS, CRACKING, BLISTERING, IRRITATION
AND DERMATITIS. INHALATION: HEADACHE, WEAKNESS, DIZZINESS,
INCOORDINATION AND POSSIBLE COLLAPSE. INGESTION: NAUSEA, VOMITING
AND DIARRHEA. MANY EFFECTSSAME AS INHALATION. CHEMICAL
PNEUMONITIS, CAN BE FATAL.
Medical Cond Aggravated by Exposure:INDIVIDUALS W/PRE-EXIST DISEASE OR
HISTORY OF AILMENTS INVOLVING THE SKIN, EYE, RESPIRATORY TRACT,
LIVER, KIDNEY, CENTRAL NERVOUS SYSTEM ARE AT GREATER RISK TO
DEVELOP ADVERSE EFFECTS W/THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/LARGE AMT OF WATER FOR 15 MIN. SKIN: WASH W/SOAP
& WATER. WASH CONTAMINATED CLOTHES BEFORE REUSE. INHALE: REMOVE
FROM EXPOSURE. IF BREATHING STOPPED OR DIFFICULT ADMIN CPR OR
OXYGEN AS NE EDED. INGEST: DO NOT INDUCE VOMITING. GIVE 1 GLASS
MILK OR 1 TO 2 OZ ACTIVATED CHARCOAL IN WATER AS TOLERATED. GET
IMMEDIATE MEDICAL AID. NOTHING BY MOUTH TO UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:35.0F,1.7C
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,WATER SPRAY,ALCOHOL OR
UNIVERSAL TYPE FOAMS AS PER MANUF RECOMMENDATIONS.
WATER/INEFFECTIVE.
Fire Fighting Procedures:FULL FIRE PROTECTIVE CLOTHES, INCL FULL-FACE
MSHA/NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS. USE WATER
TO COOL CONTAINERS/STRUCTURES & PROTECT PERSONNEL
Unusual Fire/Explosion Hazard:VAPORS:FLAM/EXPLOS MIX IN AIR. VAPOR
HEAVY/TRAVEL TO IGNITE SOURCE-FLASH. CNTNRS MAY HOLD FLAM VAPOR.
CLOSED CNTNRS MAY EXPLODE W/HEAT. EMITS IRRIT/TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP SPILL/LEAK IF AT NO RISK. AVOID:
BREATHING VAPOR; CONTACT WITH HOT LIQUIDS/FUMES; HEAT/SPARKS. TURN
OFF IGNITE SOURCES. VENTILATE AREA. INERT ABSORB TO FINISH
CLEAN-UP. REACTS W/OXIDIZING AGENTS. REPORT RELEASE (100+ LB).
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONG/REPEAT:BREATHING OF
VAPORS/MISTS/FUMES, CONTACT W/SKIN/EYES. STORE:COOL,DRY,VENTED
AREA. KEEP CNTNRS LABELED/CLOSED. NO PHYSICAL DAMAGE.
Other Precautions:GROUND & BOND DRUMS. DO NOT USE PRESSURE TO EMPTY
DRUMS. DO NOT WEAR CONTAMINATED CLOTHING. DISCARD CONTAMINATED
FOOTWEAR. KEEP AWAY FROM HEAT AND OPEN FLAME. DO NOT WEAR CONTACT
LENS WITHOUT PROPER E YE PROTECTION WHEN USING THIS PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENT NOT MAINTAIN EXPOSURES BELOW TLV USE
MSHA/NIOSH APPROVED UNITS PER 29 CFR 1910.134. IF WITHIN OSHA
LIMITS, AIR PURIFYING OV FILTER UNITS OK.
Ventilation:SUFFICIENT VENTILATION TO KEEP EXPOS BELOW CURRENT EXPOS
LIM & AREAS BELOW FLAMM VAPOR CONC. LOCAL EXHST/CONFINED AREA.
Other Protective Equipment:FACESHIELD, RESISTANT PROTECTIVE GARMENTS:
HEAD/NECK COVER, APRONS, JACKETS, PANTS, COVERALLS, BOOTS, ETC.
Work Hygienic Practices:WASH AFTER SKIN CONTACT AND BEFORE EATING,
DRINKING, USING TOBACCO OR RESTROOMS. SPRAY PAINT: USE 29 CFR
1910.107.
Supplemental Safety and Health
EMPTY CONTAINERS MAY RETAIN PRODUCT RESIDUE INCLUDING FLAMMABLE
EXPLOSIVE VAPORS. DO NOT CUT, DRILL, GRIND OR WELD ON OR NEAR
PRODUCT CONTAINERS. AIRBORNE PARTICULATE MAY BE GENERATED DURING
REMOVAL O PERATIONS INCLUDING ABRASIVE BLASTING, SANDING OR
GRINDING. READ AND UNDERSTAND MANUFACTURER'S PRECAUTIONS BEFORE
USING.
================== Physical/Chemical Properties ==================
Vapor Density:> 1
Spec Gravity:8.9 LBS/GAL
Viscosity:20" MAX/4F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY VISCOUS LIQUID WITH TYPICAL SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID OXIDIZING AGENTS, HEAT, SPARKS AND OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE UPON
THERMAL DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT IS A US EPA DEFINED IGNITABLE
HAZARDOUS WASTE. DISPOSE OF AS AN IGNITABLE WASTE IN ACCORDANCE
WITH LOCAL, STATE AND FEDERAL REGULATIONS. DOT REPORTABLE
QUANTITIES: TOLUENE: 1000 LBS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ACETONITRILE, 2856
CAGE:HO851
CAGE:HO851
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:ACETONITRILE (SARA 313) (CERCLA)
CAS:75-05-8
RTECS #:AL7700000
Fraction by Wt: 90-100%
OSHA PEL:40 PPM
ACGIH TLV:40 PPM; 60 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACRYLONITRILE (SARA 302/313) (CERCLA)
CAS:107-13-1
RTECS #:AT5250000
Fraction by Wt: <0.001%
OSHA PEL:N/K
ACGIH TLV:2 PPM, S
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SUPDAT: PVNT PERS FROM WORKING IN CONTAM ATMS.
INGEST:GASTRIC IRRIT. OTHER SYMPS PARRALLEL INHAL EXPOS. SKIN:MAY
(ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: CAUSE IRRIT. MAY BE ABSORBED W/EFTS PARALLEL TO
INHAL. EYES: SPLASH MAY CAUSE IRRIT W/REDNESS & PAIN. (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: CHRONIC: LONG TERM EXPOS MAY AFFECT LIVER, KIDNEYS &
CNS. CNTNS CHEM(S) KNOWN TO STATE OF CA TO CAUSE CANCER.
RTECS #:9999999ZZ
Ingred Name:FIRST AID:ACTIONS TO BE TAKEN IN CASE OF CYANIDE POIS
BEFORE BEGINNING WORK W/CYANIDE. OXYG & AMYL NITRITE CAN BE(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: GIVEN BY FIRST RESPONDER BEFORE MED HELP ARRIVES.
ALLOW VICTIM TO INHALE AMYL NITRITE FOR 15-30 SECS/MIN (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: UNTIL SODIUM NITRITE & SODIUM THIOSULFATE CAN BE
ADMIN BY IV (SEE NOTE TO MD). USE NEW AMYL NITRITE AMPULE(ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:EVERY 3 MIN. IF CONSCIOUS BUT SYMPS EVIDENT (NAUS,
DFCLT BRTHG, DIZZ, ETC), GIVE OXYG. IF CONSCIOUSNESS IS(ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: IMPAIRED (NON-RESPONSIVENESS, SLURRED SPEECH,
CONFUSN, DROW) OR IF UNCON BUT BRTHG, GIVE OXYG & AMYL (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: NITRITE BY MEANS OF NIOSH APPRVD RESP. IF NOT
BRTHG, GIVE OXYG & AMYL NITRITE IMMED BY NIOSH APPRVD POS (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: PRESS RESP (ARTF RESP). INHAL:REMOVE TO FRESH AIR.
ADMIN ANTIDOTE KIT & OXYG IF SYMPS OCCUR. KEEP WARM (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: & AT REST. DO NOT GIVE MOUTH TO MOUTH
RESUSCITATION. INGEST:ADMIN ANTIDOTE KIT & OXYG PER ABOVE. IF (ING
14)
RTECS #:9999999ZZ
Ingred Name:ING 13: CONSCIOUS IMMED GIVE ACTIVATED CHARCOAL SLURRY.
NEVER GIVE ANYTHING BY MOUTH IF UNCON. DO NOT INDUCE (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: VOMIT AS IT COULD INTERFERE W/RESUSCITATOR USE.
NOTE TO MD:IF PATIENT DOES NOT RESPOND TO AMYL NITRITE, (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: INJECT BY IV 10 ML OF 3% SOLN OF SODIUM NITRITE AT
RATE OF NOT MORE THAN 2.5-5 ML/MIN. ONCE ADMIN IS (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: COMPLETE FOLLOW DIRECTLY W/50 ML OF 25% SOLN OF
SODIUM THIOSULFATE AT SAME RATE BY SAME ROUTE. GIVE OXYG(ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: & KEEP UNDER OBSERVATION. IF EXPOS SEV, WATCH FOR
24-48 HRS. IF SIGNS OF CYANIDE POIS PERSIST/REAPPEAR (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: REPEAT NITRITE & THIOSULFATE INJECTIONS 1 HR LATER
IN 1/2 ORIGINAL DOSES. CYANOCABALAMIN (B12), 1 MG (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: INTRAMUSCULARLY MAY SPEED RECOVERY. TREAT MOD
CYANIDE EXPOS SUPPORTIVELY. CNTCT NEHC FOR MORE INFO .
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: DO NOT USE COMBUST MATLS. DO NOT FLUSH TO
SEWER. IF LEAK/SPILL HAS NOT IGNITED USE WATER SPRAY TO (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: PROTECT PERS & TO FLUSH SPILLS AWAY FROM EXPOS.
SPILLS CAN BE REACTED IN ALKALINE HYPOCHLORITE SOLN TO (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22: PRDCE CYANATE & THEN NEUT. RPT SPILLS IN EXCESS OF
RQ TO NRC. JT BAKER SOLUSORB SOLV ABSORB RECOM FOR SPILLS.
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR: FROM INCOMPATS. BOND & GROUND CNTNRS FOR
TRANSFERS TO AVOID SPKS. USE NON-SPKG TOOLS & EQUIP. GIVE (ING 25)
RTECS #:9999999ZZ
Ingred Name:ING 24:SPEC TRAINING TO THOSE USING CYANIDE. INSPECT
ANTIDOTES ANNUALLY FOR SHELF-LIFE. CNTCT NEHC FOR MORE INFO .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) 2460 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IN MOST CASES, CYANIDE POIS CAUSES
DECEPTIVELY HLTHY PINK TO RED SKIN COLOR. HOWEVER, IF PHYSICAL
INJURY/LACK OF OXYG INVOLVED, SKIN COLOR MAY BE BLUISH. REDDENING
OF EYES & PUPIL DILATION ARE SYMPS O F CYANIDE POIS. CYANOSIS (BLUE
DISCOLORATION OF SKIN) TENDS TO BE ASSOC W/SEV CYANIDE POIS.
INHAL:EFTS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OFTEN DELAYED, POSS DUE TO SLOW FORM
OF CYANIDE ANIONS IN BODY; THEY PVNT BODY FROM USING OXYG & CAN
LEAD TO INTERNAL ASPHY. EARLY SYMPS MAY INCL NOSE & THROAT IRRIT,
FLUSHING OF FACE & CHES T TIGHTNESS. HIGHER CONCS MAY PRDCE HDCH,
NAUS, VOMIT, RESP DEPRESS, WEAK, BLOOD CHGS, THYROID CHGS,IRREGULAR
(SUPDAT)
Medical Cond Aggravated by Exposure:WORKERS USING CYANIDE SHOULD HAVE
PREPLACEMENT & PERIODIC MED EXAMS. THOSE W/HISTORY OF CNS,
HEART/LUNG DISESASES OR LIVER, KIDNEY OR THYROID PROBS MAY BE MORE
SUSCEPTIBLE TO EFTS OF THIS SUBSTANCE.
======================= First Aid Measures =======================
First Aid:SKIN:FLUSH W/COPIOUS AMTS OF WATER. CALL MD . ADMIN ANTIDOTE
KIT & OXY PER PREPLANNED INSTRUCTIONS IF SYMPS OCCUR. EYES:IMMED
FLUSH W/POTABLE WATER FOR AT LST 15 MIN. SEEK ASSISTANCE FROM MD
(FP N). IN CASE OF CYANIDE POIS, START TREATMENT IMMED THEN GET
MED ATTN. CYANIDE ANTIDOTE KIT (AMYL NITRITE, SODIUM NITRITE &
SODIUM THIOSULFATE) SHOULD BE AVAIL IN ANY CYANDIE WORK AREA. PLAN
& (ING 6)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:36.0F,2.2C
Lower Limits:4.4%
Upper Limits:16.0%
Extinguishing Media:DRY CHEMICAL, FOAM OR CARBON DIOXIDE. WATER SPRAY
MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . IF
LEAK/SPILL HAS NOT IGNITED, USE WATER SPRAY TO DISPERSE VAPS TO
PROTECT PERS ATTEMPTING TO STOP LEAK & TO(SUPDAT)
Unusual Fire/Explosion Hazard:ABOVE FL PT, VAP-AIR MIXS EXPLO W/IN FLAM
LIMS NOTED ABOVE. VAPS CAN FLOW ALONG SURFS TO DISTANT IGNIT SOURCE
& FLASH BACK. SEALED CNTNRS MAY RUPTURE (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. REMOVE IGNIT SOURCES. WEAR APPROP
PPE. ISOLATE AREA. KEEP UNNEC & UNPROT PERS FROM ENTERING. CNTN &
RECOVER LIQ WHEN POSS. USE NON-SPKG TOOLS & EQUIP. COLLECT LIQ IN
APPROP CNTNR/ABSORB W/I NTERT MATL & PLACE IN CHEM WASTE CNTNR.(ING
21)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DMG. STORE IN
COOL, DRY, WELL-VENTD AREA AWAY FROM WHERE FIRE HAZ MAY BE ACUTE.
OUTSIDE/DETACHED STOR PREF. SEPARATE (ING 24)
Other Precautions:PROPER USE & MAINT OF PROT EQUIP ESSNTL. MATL CNTNRS
MAY BE HAZ WHEN EMPTY; OBSERVE WARNINGS & PRECS. DO NOT CLEAN EMPTY
CNTNRS. DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND/EXPOSE CNTNRS TO ANY IGNIT SOURCES; MAY EXPLODE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF THE EXPOSURE LIMIT IS EXCEEDED, WEAR NIOSH
APPROVED SUPPLIED AIR, FULL-FACEPIECE RESPIRATOR, AIRLINED HOOD OR
FULL-FACEPIECE SCBA. THIS SUBSTANCE HAS POOR WARNING PROPERTIES.
Ventilation:SYS OF LOC &/OR GEN EXHST RECOM. LOC EXHST PREF BECAUSE IT
CAN CONTROL EMISSIONS OF CONTAMINANT AT ITS SOURCE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
IMPERVIOUS PROT CLTHG INCL BOOTS, LAB COAT, APRON OR COVERALLS.
Work Hygienic Practices:WORKERS MUST CAREFULLY FOLLOW GOOD HYGIENIC
PRACTS INCLUDING NO EATING, DRINKING OR SMOKING IN WORKPLACE.
Supplemental Safety and Health
FIRE FIGHT PROCS: FLUSH SPILLS AWAY FROM EXPOS. MAY EMIT TOX & FLAM
FUMES OF CYANIDE IF INVOLVED IN FIRE. EXPLO HAZ: WHEN HEATED.
SENSITIVE TO STATIC DISCHARGE. EFTS OF OVEREXP: HEARTBEAT, ABDOM
PAIN, CONVULS, SHOCK, UNCON & DEATH, DEPENDING ON CONC & TIME OF
EXPOS. MATL HAS INSUFFICIENT WARNING PROPERTIES TO (ING 3)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:180F,82C
Melt/Freeze Pt:M.P/F.P Text:-51F,-46C
Vapor Pres:73 @ 20C
Vapor Density:1.4
Spec Gravity:0.79
Evaporation Rate & Reference:5.79 (BUAC=1)
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; ETHER ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPAT W/OXIDIZING MATLS, SULFURIC ACID, OLEUM, CHLOROSULFONIC ACID,
N-FLUORO CMPDS, NITRATING AGENTS & PERCHLORATES.
Stability Condition to Avoid:HEAT, FLAMES, IGNITION SOURCES AND
INCOMPATIBLES.
Hazardous Decomposition Products:BURNING MAY PRODUCE FUMES OF CYANIDE,
CARBON MONOXIDE, CARBON DIOXIDE, NITROGEN OXIDES AND SULFUR OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECOVERY OR
RECYCLING SHOULD BE HANDLED AS HAZ WASTE & SENT TO RCRA APPRVD
WASTE FACILITY. PROCESSING, USE/CONTAM MAY CHANGE WASTE MANAGEMENT
OPTIONS. DISPOSE OF CNTNR & U NUSED CONTENTS I/A/W FED, STATE & LOC
REQS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:D139R, 2,4-D L.V. 4 ESTER
Resp. Party Other MSDS Num.:139
CAGE:LO771
Contract Num:SP0411-01-W-E823
CAGE:0TNN7
CAGE:LO771
============= Composition/Information on Ingredients =============
Ingred Name:ISOCTYL (2-ETHYLHEXYL) ESTER OF 2,4-DICHLOROPHENOXYACETIC
ACID
CAS:1928-43-4
RTECS #:AG8525000
= Wt:67.2
OSHA PEL:10 MG/M3 (2,4-D ACID
Ingred Name:KEROSENE AND EMULSIFIER
CAS:8008-20-6
RTECS #:OA5500000
= Wt:32.8
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION-THIS PRODUCT CONTAINS
PETROLEUM DISTILLATES. EXCESSIVE INHALATION MAY CAUSE RESPIRATORY
IRRITATION, DIZZINESS, WEAKNES, NAUSEA, HEADACHE, OR POSSIBLE
UNCONSCIOUSNESS. EYES- MAY CAUSE SLIGHT EYE IRRITATION. SKIN-MAY
CAUSE MILD SKIN IRRITATION OR DERMAL SENSITIZATION REACTIONS IN
SOME INDIVIDUALS. HARMFUL IF ABSORBED THROUGH SKIN. PROLONGED OR
REPEATED OVEREXPOSURE MAY RESULT IN EFFECTS S IMILAR TO THOSE
CAUSED BY INGESTION. INGESTION-MAY CAUSE MUSCLE WEAKNESS, NAUSEA,
DIARRHEA, & ABDOMINAL PAIN. FALL IN BLOOD PRESSURE OR MYOTONIA
(PROLONGED MUSCULAR SPASM) MAY OCCUR UNDER EXTREME EXPO SURE
CONDITIONS. CAN BE FATAL.
Explanation of Carcinogenicity:THE CURRENT SCIENTIFIC CONSENSES IS THAT
THERE IS NO PROVEN CAUSAL ASSOCIATION BETWEEN 2,4-D & CANCER.
RECENT STUDIES HAVE NOT SHOWN 2,4-D TO BE A MUTAGEN OR TERATOGEN.
Effects of Overexposure:NONSPECIFIC: MUSCLE WEAKNESS, LETHARGY, LOSS OF
APPETITE, ABDOMINAL PAINS, HEADACHES, OR SHORTNESS OF BREATH.
Medical Cond Aggravated by Exposure:SKIN EXPOSURE MAY AGGRAVATE
EXISTING SKIN CONDITIONS. EXPOSURE TO MIST MAY AGGRAVATE EXISTING
RESPIRATORY CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYE-HOLD EYELIDS OPEN & FLUSH ENTIRE EYE WITH A STEADY,
GENTLE STREAM OF WATER FOR 15 MINS. GET MEDICAL ATTENTION.
INHALATION-REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BRE ATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL
ATTENTION IMMEDIATELY. INGESTION-CALL A PHYSICIAN OR POISON CONTROL
CENTER. DO NOT INDUCE VOMITING. DRINK PROMPTLY A LARGE QUANTITY OF
MILK, EGG WHITES, G ELATIN SOLUTIN, OR IF THESE ARE NOT AVAILABLE,
DRINK LARGE QUANTITIES OF WATER. AVOID ALCOHOL. DO NOT GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. SKIN-WASH AFFECTED AREA
WITH SOAP & WATER. IF IRR ITATION PERSISTS, GET MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=66.7C, 152.F
Extinguishing Media:USE CO2 OR DRY CHEMICAL FOR SMALL FIRES AND WATER
FOG OR FOAM FOR LARGE FIRES. USE WATER SPRAY TO COOL CLOSED
CONTAINERS.
Fire Fighting Procedures:MAY PRODUCE TOXIC AND NOXIOUS FUMES UNDER
EXTREME FIRE CONDITIONS. USE POSITIVE PRESSURE SELF-CONTAINED
BREATHING APPARATUS AND ACID RESISTANT PROTECTIVE CLOTHING. ANY
WATER USED TO EXTINGUISH THE FIR E SHOULD BE CONTAINED BY DIKE TO
PREVENT CONTAMINATION OF THE PUBLIC WATER SYSTEM.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE THE FLASH POINT THIS
MATERIAL EMITS FLAMMABLE VAPORS WHICH, WHEN MIXED WITH AIR, CAN
BURN OR BE EXPLOSIVE. FINE MIST OR SPRAY MAY BE FLAMMABLE AT
TEMPERATURES BELOW THE FLASH POINT. COMBUSTION PRODUCTS MAY
INCLUDE, BUT ARE NOT LIMITED TO: HYDROGEN CHLORIDE AND NITROGEN
OXIDES.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR THE SUGGESTED SAFETY EQUIPMENT WHEN
CLEANING LARGE SPILLS. SURROUND WITH IMPERVIOUS MATERIAL SUCH AS
DIRT TO PREVENT RUN-OFF. ABSORB PRODUCT WITH AN INERT ABSORBENT
(CLAY GRANULES OR SAWDUST). CO NTAIN ALL AFFECTED MATERIAL IN A
CLOSED, MARKED CONTAINER FOR PROPER DISPOSAL. TREAT CONTAMINATED
AREA WITH DETERGENT & WATER. 2, 4-D SPILLS ARE SUBJECT TO CERCLA
(SUPERFUND) REPORTING REQUIREMENTS.
======================Handling and Storage ======================
Handling and Storage Precautions:ALWAYS USE ORIGINAL CONTAINER TO STORE
PESTICIDES IN A SECURED WAREHOUSE OR STORAGE BUILDING. DO NOT STORE
SEEDS, FERTILIZERS, INSECTICIDES OR FUNGICIDES. CONTAINERS SHOULD
BE OPENED IN WELL VENTILATE D AREAS. DO NOT CONTAMINATE WATER, FOOD
OR FEED BY STORAGE OR DISPOSAL.
Other Precautions:HANDLING & STORAGE: KEEP CONTAINER TIGHTLY SEALED
WHEN NOT IN USE. DO NOT STACK CARDBOARD CASES MORE THAN TWO PALLETS
HIGH.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED PESTICIDE RESPIRATOR
WHEN EXPOSED TO MIST.
Ventilation:OPEN VENTILATION. REDUCE ALL MIST WITH LOCAL EXHAUST.
STATEMENT OF PRODUCT LABEL).
BROW & TEMPLE PROTECTION.
Other Protective Equipment:LONG SLEEVED SHIRT, LONG PANTS, SOCKS AND
SHOES. (SEE PRECAUTIONARY STATEMENTS ON PRODUCT LABEL)
Work Hygienic Practices:WASH HANDS BEFORE EATING, DRINKING, CHEWING
GUM, USING TOBACCO, OR USING THE TOILET. REMOVE CLOTHING
IMMEDIATELY IF PESTICIDE GETS INSIDE. THEN WASH THOROUGHLY AND PUT
ON CLEAN CLOTHING.
Supplemental Safety and Health
HYGIENIC PRACTICES: REMOVE PROTECTIVE EQUIPMENT AFTER HANDLING THIS
POSSIBLE, WASH THOROUGHLY AND CHANGE INTO CLEAN CLOTHING.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:>204.4C, 400.F
Melt/Freeze Pt:M.P/F.P Text:N/D
Vapor Pres:(MM HG @ 20C): <1
Spec Gravity:1.034
pH:N/D
Solubility in Water:100% EMULSIFIABLE (CAN BE
Appearance and Odor:DARK AMBER LIQUID, AROMATIC (SOLVENT) ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS OR ACIDS.
Stability Condition to Avoid:AVOID HEAT CONDITIONS.
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:ACUTE ORAL LD50: 1250 MG/KG. ACUTE DERMAL
LD50: >2000 MG/KG. ACUTE INHALATION LC50: >5 MG/L. EYE IRRITATION:
MINIMAL IRRITATION. DERMAL IRRITATION: MINIMAL IRRITATION. DERMAL
SENEITIZATION: IS A SENSI TIZER. CHRONIC EFFECTS: REPEATED OR
PROLONGED OVEREXPOSURE TO PHENOXY HERBICIDES MAY CAUSE LIVER,
KIDNEY, GASTROINTESTINAL OR MUSCULAR SYSTEM EFFECTS. THE EPA'S
SCIENCE ADVISORY PANEL HAS GIVEN 2,4-D A CLASS D CLASSIFICATION
(NOT CLASSIFIABLE AS HUMAN CARCINOGENICITY). VARIOUS
EPIDEMIOLOGICAL STUDIES HAVE YIELDED CONFLICTING RESULTS WITH THE
MAJORITY BEING NEGATIVE.
===================== Ecological Information =====================
Ecological:2,4-D HAS A RELATIVELY SHORT HALF-LIFE (ON AVERAGE 6-9 DAYS
IN SOIL, 6-7 IN GRASS) AND IS REDILY DEGRADED INTO NONTOXICOLOGICAL
SUBSTANCES BY SOIL MICROBES AND AQUATIC MICROOORGANISMS. RESEARCH
HAS SH OWN THAT 2,4-D DOES NOT BIOACCUMULATE TO ANY SIGNIFICANT
DEGREE IN MAMMALS OR IN OTHER ORGANISMS. ECOTOXICITY: THIS PRODUCT
IS TOXIC TO AQUATIC INVERTEBRATES. DRIFT OR RUNOFF MAY ADVERSELY
AFFECT QUAT IC INVERTEBRATES AND NONTARGET PLANTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PESTICIDE WASTES ARE TOXIC. IMPROPER DISPOSAL OF
EXCESS PESTICIDE SPRAY MIXTURES OR RINSATE IS A VIOLATION OF
FEDERAL LAW & MAY CONTAMINATE GROUNDWATER. IF PRODUCT CANNOT BE
DISPOSED OF BY USE ACCORDI NG TO THE LABEL, CONTACT YOUR STATE
PESTICIDE OR ENVIRONMENTAL CONTROL AGENCY OR THE HAZARDOUS WASTE
REPRESENTATIVE AT THE NEAREST EPA REGIONAL OFFICE
=================== MSDS Transport Information ===================
Transport Information:DOT REGULATED CONTAINER SIZE: 30 GAL, 55 GAL, 220
GAL, 260 GAL (ALL SMALLER CONTAINER SIZES ARE NOT DOT REGULATED).
HAZARD CLASS: 3. UN NUMBER: NA 1993. PACKING GROUP: III. GUIDE
NUMBER: 128. PROPER S HIPPING NAME: RQ COMBUSTIBLE LIQUID, N.O.S.,
(CONTAINS KEROSENE, 2, 4-D ESTER).
===================== Regulatory Information =====================
SARA Title III Information:SARA TITLE III; SECTION 311/312: AN
IMMEDIATE & DELAYED HEALTH HAZARD. A FIRE HAZARD. SARA TITLE III;
SECTION 313-THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT
TO THE REPORTING REQUIREMENTS O F THE SUPERFUND AMENDMENTS &
REAUTHORIZATION ACT OF 1986 & 40 CFR PART 372: 2,4-D 2-ETHYLHEXYL
ESTER, CAS#: 1928-43-4.
Federal Regulatory Information:REPORTABLE QUANTITY (RQ): 100 LBS OF
2,4-D ACID EQUIVALENT OR APPROXIMATELY 26 GALLONS OF 2,4-D L.V.
4ESTER. FOR RELEASES GREATER THAN THE RQ, CONTACT THE NATIONAL
RESPONSE CENTER AT (800) 424-8802.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:THERMAL-ACOUSTICAL BATTS
CAGE:FO261
CAGE:FO261
CAGE:75165
============= Composition/Information on Ingredients =============
Ingred Name:GLASS OXIDE, FIBER GLASS WOOL, LEAD BOROSILICATE GLASS
ENAMEL FLUX
CAS:65997-17-3
Fraction by Wt: 85-98%
Ingred Name:PHENOL, UREA, FORMALDEHYDE RESIN
CAS:25104-55-6
Fraction by Wt: 2-15%
Ingred Name:KRAFT, FOIL/KRAFT, PSK, FSK, AND VARIOUS METAL BUILDING
FACINGS
Fraction by Wt: <1-6.7%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF THE UPPER
RESPIRATORY TRACT MAY OCCUR. SKIN/EYES: TEMPORARY IRRITATION.
INGESTION: MAY CAUSE TEMPORARY IRRITATION TO THE GI TRACT/STOMACH.
MAY AFFECT THE THROAT, LUNGS & SKIN /EYES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, SCRATCHY THROAT, COUGHING,
CONGESTION, REDNESS, ITCHING
Medical Cond Aggravated by Exposure:PRE-EXISTING CHRONIC RESPIRATORY,
SKIN/EYE DISEASES/CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. DRINK WATER TO CLEAR THROAT
& BLOW NOSE TO REMOVE FIBERS & DUSTS. SKIN: WASH GENTLY W/SOAP &
WARM WATER TO REMOVE DUST & FIBERS. WASH HANDS BEFORE EATING/USING
THE RES TROOM. INGESTION: TREAT SYMPTOMATICALLY. RINSE MOUTH
W/WATER TO REMOVE FIBERS & DRINK PLENTY OF WATER. EYES: DON'T
RUB/SCRATCH. FLUSH W/LARGE AMOUNTS OF WATER FOR 5-15 MINS. (SEE
SUPP)
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, WATER, WATER FOG, DRY CHEMICAL
Fire Fighting Procedures:USE NORMAL FIRE FIGHTING PROCEDURES TO PREVENT
INHALATION OF SMOKE & GASES.
Unusual Fire/Explosion Hazard:NO POTENTIAL FOR FIRE/EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:PICKUP LARGE PIECES. VACUUM DUSTS. IF SWEEPING
IS NECESSARY, USE A DUST SUPPRESANT SUCH AS WATER. DON'T DRY SWEEP
DUST ACCUMULATION/USE COMPRESSED AIR FOR CLEAN-UP. THESE PROCEDURS
WILL HELP TO MINIMI ZE POTENTIAL EXPOSURES.
======================Handling and Storage ======================
Handling and Storage Precautions:USE PROTECTIVE EQUIPMENT WHEN HANDLING
UNCONTAMINATED MATERIAL. WAREHOUSE STORAGE SHOULD BE IAW/PACKAGE
DIRECTIONS, IF ANY.
Other Precautions:KEEP DRY & PROTECT FROM ELEMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED DUST/MIST RESPIRATOR(3M
9900 & MOLDEX 200)/EXPOSURE EXCEEDING TEN TIMES, A NIOSH APPROVED
HALF MASK RESPIRATOR W/HEPA FILTER CARTRIDGE(MSA COMFO II W/H
CARTRIDGES & THE SURVIVAIRHALF MASK W/#1090-00 CARTRIDGES.
Ventilation:LOCAL EXHAUST TO REMOVE AIRBORNE DUST & FIBERS. GENERAL
DILUTION: TO KEEP AIRBORNE DUST & FIBERS BELOW APPLICABLE LIMITS
Other Protective Equipment:BARRIER CREAMS, LOOSE FITTING, LONG SLEEVED
CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. USE A VACUUM CLEANER BEFORE REPAIR/MAINTENANCE TO REMOVE
DUST/FIBERS.
Supplemental Safety and Health
APPEARANCE CONT'D: GOLD TO YELLOW FIBROUS GLASS BOARD, BATT,
BLANKETT/LOOSE FILL INSULATION W/W/O KRAFT, FSK/OTHER FACINGS, NO
SIGNIFICANT ODOR. FIRST AID CONT'D: OBTAIN MEDICAL ATTENTION IN ALL
CASES .
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1300F
Solubility in Water:INSOLUBLE
Appearance and Odor:(SEE SUPP)
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:PYROLYSIS/BURNING; OF THE RESIN
Hazardous Decomposition Products:CO2, CO, CARBON PARTICLES,
FORMALDEHYDE & TRACES OF HYDROGEN CYANIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NAPA OIL TREATMENT / NAPA OIL TREATMENT 9300
Resp. Party Other MSDS Num.:505.0173630-007.008
CAGE:72527
CAGE:81355
Contract Num:SP0450-99-M-C328
CAGE:0PGK2
CAGE:72527
============= Composition/Information on Ingredients =============
Ingred Name:DISTILLATES (PETROLEUM), SOLVENT-DEWAXED HEAVY
PARAFFINIC/ALIPHATIC PETROLEUM DISTILLATES
CAS:64742-65-0
Code:F
RTECS #:PY8038500
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:BENZENE, ETHENYL-, POLYMER WITH 2-METHYL-1,3-BUTADIENE,
HYDROGENATED/STYRENE-ETHYLENE/PROPYLENE BLOCK COPOLYMER
CAS:68648-89-5
Code:F
Minumum % Wt:1.
Maxumum % Wt:10.
Other REC Limits:NONE RECOMMENDED
Ingred Name:PHOSPHORODITHIOIC ACID, O,O-DI-C1-14-ALKYL ESTERS, ZINC
SALTS/ZINC C1-C14 ALKYLDITHIOPHOSPHATE
CAS:68649-42-3
Code:F
= Wt:1.9
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ACGIH TLV 5 MG/M3 - TWA OIL MIST
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: UNKNOWN. ACUTE -
INHALATION: BREATHING OF VAPOR OR MIST IS POSSIBLE. EYE: LIQUID
CONTACT WITH EYES MAY RESULT IN MILD IRRITATION AND REDNESS. SKIN:
LIQUID CONTACT MAY RESULT IN IRRITAT ION, BURNING OF SKIN, AND
OTHER SKIN DAMAGE. SWALLOWING: SWALLOWING SMALL AMOUNTS OF THIS
MATERIAL DURING NORMAL HANDLING IS NOT LIKELY TO CAUSE HARMFUL
EFFECTS. SWALLOWING LARGE AMOUNTS MAY BE HARMFU L. CHRONIC -
UNKNOWN.
Explanation of Carcinogenicity:NO DATA
Effects of Overexposure:STINGING, TEARING, REDNESS OF EYES; REDNESS,
BURNING, DRYING AND CRACKING OF SKIN; NAUSEA, VOMITING, DIARRHEA,
IIRRITATION OF NOSE, THROAT, RESPIRATROY TRACT
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMS DEVELOP, MOVE INDIVIDUAL AWAY FROM
EXPOSURE AND INTO FRESH AIR. IF SYMPTOMS PERSIST, SEEK MEDICAL
ATTENTION. IF BREATHING IS DIFFICULT, ADMINISTER OXYGEN. EYE
CONTACT: IF SYMP TOMS DEVELOP, MOVE INDIVIDUAL AWAY FROMEXPOSURE
AND INTO FRESH AIR. FLUSH EYE GENTLY WITH WATER WHILE HOLDING
EYELIDS APART. IF SYMPTOMS PERSIST, SEEK MEDICAL ATTENTION. SKIN:
REMOVE CONTAMINATED CLO THING. WASH EXPOSED AREA WITH SOAP AND
WATER. IF SYMPTOMS PERSIST, SEEK MEDICAL ATTENTION. LAUNDER
CLOTHING BEFORE REUSE. INGESTION: DO NOT INDUCE VOMITING. GIVE ONE
GLASS OF MILK OR WATER, AND SEEK MEDICAL ATTENTION. DO NOT LEAVE
VICTIM
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:=201.7C, 395.F
Lower Limits:N/D
Upper Limits:N/D
Extinguishing Media:REGULAR FOAM, CARBON DOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WATER OR FOAM MAY CAUSE FROTHING WHICH CAN BE
VIOLENT AND POSSIBLY ENDANGER THE LIFE OF THE FIREFIGHTER. WEAR A
SELF-CONTAINED BREATHING APPARATUS WITH A FULL FACEPIECE OPERATED
IN THE POSITIVE PRESSU RE DEMAND MODE WITH APPROPRIATE TURN-OUTGEAR
AND CHEMICAL RESISTANT PERSONAL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUM (EVEN EMPTY) BECAUSE PRODUCT (EVEN JUST RESIDUE) CAN
IGNITE EXPOSIVELY. DENSE SMOKE MAY BE GENERATED WHILE BURNING.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. STOP SPILL AT
SOURCE, DIKE AREA OF LARGE SPILLS TO PREVENT SPREADING, PUMP
LIQUID TO SALAVAGE TANK. REMAINING LIQUID OR SMALL SPILLS MAY BE
TAKEN UP ON SAND, CLAY, EARTH, F LOOR ABSORBENT OR OTHER ABSORBENT
MATERIALAND SHOVELED INTO CONTAINERS FOR DISPOSAL. CLEAN AREA
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION. PREVENT RUNOFF FROM
ENTERING SEWERS/WATERWAYS.
======================Handling and Storage ======================
Other Precautions:CONTAINERS OF THIS MATERILA MAY BE HAZARDOUS WHEN
EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES (VAPORS,
LIQUID, AND/OR SOLID), ALL HAZARD PRECAUTIONS GIVEN IN THE DATA
SHEET MUST BE OBSER VED. KEEP OUT OF REACH OF CHILDREN. AVOID
BREATHING VAPORS OR MIST. DO NOT GET IN EYE, ON SKIN OR ON
CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
HOWEVER, IF OIL MISTS ARE GENERATED ABOVE RECOMMENDED PEL/TLV OF 5
MG/M3, THEN A NIOSH/MSHA APPROVED RESPIRATOR IS ADVISED IN ABSENCE
OF PROPER ENVIRONMENT AL CONTROL.
Ventilation:NOT REQUIRED UNDER NORMAL CONDITIONS. IF UNUSUAL OPEATING
CONDITIONS EXIST, THEN PROVIDE SUFFICIENT MECHANICAL VENTILATION TO
MAINTAIN EXPOSURE BELOW PEL/TLV.
IF MISTING OR SPLASHING
Other Protective Equipment:WEAR NORMAL WORK CLOTHING COVERING ARMS AND
LEGS. EYE BATH, WASHING FACILITY
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH AFTER HANDLING AND BEFORE EATING,
DRINKING OR SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:NO DATA
Spec Gravity:.878 @ 60 F
Viscosity:1100.0-1400.0 CST
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:AMBER LIQUID WITH PETROLEUM ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY FORM CARBON DIOXIDE AND CARBON
MONOXIDE, VARIOUS HYDROCARBONS.
Conditions to Avoid Polymerization:PRODUCT WILL NOT UNDERGO HAZARDOUS
POLYMERIZATION.
=================== Toxicological Information===================
Toxicological Information:NO DATA
===================== Ecological Information =====================
Ecological:NO DATA
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL LAWS AND REGULATIONS.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 313: ZIN C1-C14 ALKYLDITHIOPHOSPHATE
Federal Regulatory Information:TSCA STATUS: THE INTENTIONAL INGREDIENTS
OF THIS PRODUCT ARE LISTED ON THE TOXIC SUBSTANCE CONTROL ACT
(TSCA) INVENTORY REPORTING LIST.
State Regulatory Information:NONE
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:6700, PURE WHITE SPRED ULTRA EXTERIOR GLOSS LATEX (SUPDAT)
CAGE:72818
CAGE:72818
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:C 50 PPM, VAPOR
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BARIUM, CALCIUM, MAGNESIUM, STRONTIUM, ALUMINUM SILICATE
FLUX
CAS:66402-68-4
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALUMINUM HYDROXIDE
CAS:21645-51-2
RTECS #:BD0940000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER WITH
2,2,4-TRIMETHYL-1,3-PENTANEDIOL
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA GEL
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 1-5%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:TITANIUM OXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10-20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:ACRYLIC COPOLYMER
Fraction by Wt: 10-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STYRENE ACRYLIC COPOLYMER
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 50-60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND: 95.67 GR/LTR
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:LIVER DMG, KIDNEY DMG. REPROD SYS DMG, PULM EDEMA,
LOSS OF CONSCIOUSNESS, ACUTE POISONING, RESP FAILURE (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:CARDIAC FAILURE, BRIAN DMG, DEATH. SUPP HLTH
INFO:OTHER EFTS OF OVEREXP MAY INCL TOX TO LIVER, KIDNEY, (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:LUNGS, BLOOD, REPROD SYS. MAY BE ABSORBED THRU SKIN.
NOTICE-RPTS HAVE ASSOC RPTD & PRLNGD OCCUP OVEREXP (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:TO SOLV W/PERM BRAIN & NERV SYS DMG. INTENTIONAL
MISUSE BY DELIB CONCENTRATING & INHALING CONTENTS MAY BE(ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:HARMFUL/FATAL. SOME LAB TESTS RSLTS HAVE SHOWN
ETHYLENE GLYCOL TO BE AN ANIMAL TERATOGEN, NUISANCE DUST (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:HAZARD-OVEREXPOSURE MAY CAUSE MECHANICAL IRRITATION
OF EYES, SKIN & RESPIRATORY TRACT.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:OCCURS, CONSULT PHYS. EYE:FLUSH IMMED W/LG
AMTS OF WATER, ESPECIALLY UNDER LIDS FOR @ LST 15 (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:MINS. IF IRRIT OR OTHER EFTS PERSIST, OBTAIN MED
TREATMENT. INGEST:OBTAIN MED TREATMENT IMMEDIATELY.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:LG SPILLS-SHUT OFF LEAK IF SAFE TO DO SO. DIKE &
CONTAIN SPILL. PUMP TO STOR/SALVAGE VESSELS. USE (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:ABSORB TO PICK UP EXCESS RESIDUE. KEEP SALVAGEABLE
MATL & RINSE WATER OUT OF SEWERS & WATER COURSES. SM (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:SPILLS-USE ABSORBENT TO PICK UP RESIDUE & DISPOSE OF
PROPERLY.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:SURFACES. IF SUCH CNDTNS CANNOT BE AVOIDED, USE
APPROP RESP PROT AS DIRECTED UNDER SPEC PROT INFO (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:EMPTY CONTAINERS MAY CONTAIN HAZARDOUS RESIDUES.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRIT OF RESP TRACT,
LUNGS, PRLNGD INHAL MAY LEAD TO MUC MEMB IRRIT, DROW, DIZZ AND/OR
LT HEAD, HDCH, NAUS, GI DISTURB, COUGH, CHOKING SNEEZING, APATHY,
CNS DEPRESS, RESP PROBLEMS, ANESTHEFT/NARCOSIS, DFCLTY OF BRTHG,
BLOOD ABNORMAL, KIDNEY DMG, PNEUMOCONIOSIS, LOSS OF CONSCIOUSNESS.
SKIN:(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:IRRIT. PRLNGD/RPTD CONT CAN CAUSE
DERM. CONT MAY RSLT IN DERMAL ABSORP OF COMPONENT(S) OF THIS PROD
WHICH MAY CAUSE APATHY. EYE:IRRIT. PRLNGD/RPTD CONT CAN CAUSE CONJ,
TEARING, REDNESS, SEV I RRIT/BURNS, CORNEAL INJURY, BLNDNESS.
INGEST:MAY CAUSE MOUTH & THROAT IRRIT, DROW, DIZZ AND/OR LT HEAD,
HDCH, (SUPDAT)
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS
ASTHMA-LIKE CONDITIONS, KIDNEY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET MED ATTN. HAVE TRAINED PERSON GIVE OXYG IF NEC. GET MED HELP
FOR ANY BRTHG DFCLTY. REMOVE TO FRESH AIR IF INHAL CAUSE EYE
WATERING, HD CH, DIZZ/OTHER DISCOMFORT. GET MED ATTNIF
DISCOMFORT/IRRIT PERSISTS. SKIN:FLUSH W/WATER, THEN WASH THORO
W/SOAP & WATER. REMOVE CONTAMD CLTHG. WASH CONTAMD CLTHG BEFORE
RE-USE. IF IRRIT (ING 17)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL OR FOAM WATER FOG, CARBON DIOXIDE.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . WATER
MAY BE USED TO COOL & PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL LONG DIST
TO SOURCE OF IGNIT & FLASH BACK. CLSD CNTNRS MAY BURST IF EXPOSED
TO EXTREME HEAT/FIRE. MAY DECOMPOSE UNDER FIRE(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY W/ALL APPLIC HLTH & ENVIR REGS. ELIM
ALL SOURCES OF IGNIT. VENTILATE AREA. SPILLS MAY BE COLLECTED
W/ABSORB MATLS. EVAC ALL UNNEC PERS. PLACE COLLECTED MATL IN PROPER
CNTNRS. COMPLETE PERSONAL PROT EQUIP MUST BE USED DURING
CLEANUP.(ING 19)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <100F. KEEP AWAY FROM HEAT, SPKS
& OPEN FLAME. KEEP FROM FREEZING. DO NOT STORE IN ALUMINUM CNTNRS.
USE W/ADEQ VENT. DO NOT TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID CONT W/SKIN &
EYES, & BRTHG OF VAPS. KEEP CNTNRS TIGHTLY CLSD & UPRIGHT WHEN NOT
IN USE. AVOID CNDTNS WHICH RSLT IN FORMATION OF INHALABLE PARTICLES
SUCH AS SPRAYI NG/ABRADING(SANDING) PAINTED (ING 22)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
ONLY NIOSH APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29
CFR 1910.134.
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
IMPERVIOUS CLOTHING, APRON.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING,
ESPECIALLY BEFORE EATING OR SMOKING.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:HOUSE & TRIM PAINT, EXPLO HAZ:CNDTNS EMITTING
IRRITANT AND/OR TOXIC GASES. IN CLSD TANKS, WATER/FOAM MAY CAUSE
FROTHING/ERUPTION. MATLS TO AVOID:POTASSIUM. EFTS OF OVEREXP:UNCOO
RDINATION, NAUS, VOMIT, GI DISTURB, SEVABDOM PAIN, APATHY, CNS
DEPRESS, RESP PROBLEMS, INTOXICATION, (ING 11)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:64.08
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, ALKALIS ALUMINUM, ZINC, HYPOCHLORITES,
HYDROGEN FLUORIDE, MAGNESIUM, CAUSTICS, SODIUM, (SUPDAT)
Stability Condition to Avoid:ELEVATED TEMPS, CONT W/OXIDIZING AGENT,
ALUMINUM OR ZINC, STOR NEAR ACIDS, FREEZING, SPKS, OPEN FLAME,
IGNIT SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, ACRID FUMES, OXYGEN, TOXIC GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. AVOID DISCHARGE TO NATURAL
WATERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LIMESTONE
CAGE:APGLI
CAGE:APGLI
============= Composition/Information on Ingredients =============
Ingred Name:CARBONIC ACID, CALCIUM SALT (1:1); (LIMESTONE)
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 100%
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS MATERIAL IS NOT TOXIC. IT IS A
COMMON AIR CONTAMINANT- NO TOXIC EFFECTS FROM POWDERED LIMESTONE
ARE NOTICED WHERE AIR CONTAINS CONTAMINATE TO EXCESS. PERSONS
SUBJECTED TO LARGE AMOUNTS OF THIS DU ST WILL BE FORCED TO LEAVE
AREA BECAUSEOF NUISANCE CONDITIONS: COUGHING, SNEEZING, AND NASAL
IRRITATION FROM DUST.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MIN. CALL PHYS IF
IRRITATION CONTINUES. SKIN: WASH CONTAMINATED AREA WITH WATER.
INHAL: REMOVE TO FRESH AIR. INGEST: CALL MD IMMED .
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NOT COMBUSTIBLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
SHOULD BE USED IF MATL IS INVOLVED IN FIRE SITUATION DUE TO POTNTL
OF READILY LIBERATING CO2 & POSS OF(SUPDAT)
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OR VACUUM MATERIAL FROM SPILLAGE INTO A
WASTE CONTAINER FOR DISPOSAL. AVOID DUSTING CONDITIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:BE SURE PROPER VENTILATION AND
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN DUSTY CONDITION EXISTS, WEAR NIOSH/MSHA
APPROVED DUST MASK TO GUARD AGAINST NUISANCE PARTICLES. IN ABSENCE
OF DUST OR MIST, MECHANICAL EXHAUST IS SUFFICIENT.
Ventilation:PROVIDE GENERAL VENTILATION AND LOCAL EXHAUST VENTILATION
TO MEET TLV REQUIREMENTS.
Other Protective Equipment:PROTECTIVE CLOTHING USUALLY NOT NEEDED, BUT
MAY BE DESIRABLE IN SPECIFIC WORK SITUATIONS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: DISPERSION OF DUST.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:500C DECOMP
Spec Gravity:2.7-3.0
Solubility in Water:0.002 G/100G
Appearance and Odor:WHITE POWDER OR LUMP ROCK, LOW ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL CAN BE DISPOSED OF AS INERT SOLID IN A
LANDFILL OR BY OTHER PROCEDURES WHICH ARE ACCEPTED UNDER FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ACETONE, A930-4
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE; (2-PROPANONE) (SARA 313) (CERCLA)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 99%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM;1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SUPP DATA:CHLORIDE, HEXACHLOROMELAMINE, NITROSYL
PERCHLORATE, NITRYL PERCHLORATE, PERMONOSULFURIC ACID, (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:THIODIGLYCOL + HYDROGEN PEROXIDE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 5800 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:PRDCES IRRIT, CHARACT BY
BURNING SENSATION, REDNESS, TEARING, INFLAMM & POSS CORNEAL INJURY.
SKIN:EXPOS MAY CAUSE IRRIT CHARACT BY REDNESS, DRYNESS & INFLAMM.
INGEST:MAY CAUSE IRRIT OF DIGES T TRACT. MAY CAUSE CNS DEPRESS,
KIDNEY DMG & LIVER DMG. SYMPS MAY INCL:HDCH, EXCITEMENT, FATG,
NAUS, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:VOMIT, STUPOR & COMA. INHAL:INHAL OF
HIGH CONCS MAY CAUSE CNS EFTS CHARACT BY HDCH, DIZZ, UNCON & COMA.
CAUSES RESP TRACT IRRIT. MAY CAUSE LIVER & KIDNEY DMG. MAY CAUSE
MOTOR INCOORD & SPEECH ABNORMS. CHRONIC:PRLNG/RPTD SKIN CONT MAY
CAUSE DERM. CHRONIC INHAL MAY CAUSE EFTS SIMILAR TO THOSE OF ACUTE
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS, OCCAS
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN:FLUSH W/PLENTY
OF SOAP & WATER FOR AT LST 15 MINS WHILE REMOVING CONTAM CLTHG &
SHOES. GET ME D AID IF IRRIT DEVELOPS/PERSISTS. INGEST:IF VICTIM IS
CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. GET MED AID
IMMED. INHAL:GET MED AID IMMED. REMOVE FROM EXPOS TO FRESH AIR
IMMED. IF (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:-4F,-20C
Lower Limits:2.5%
Upper Limits:12.8%
Extinguishing Media:FOR SM FIRES, USE DRY CHEM, CARBON DIOXIDE, WATER
SPRAY/ALCOHOL-RESIST FOAM. FOR LG FIRES, USE WATER SPRAY,
FOG/(SUPDAT)
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:CONTAINERS CAN BUILD UP PRESSURE IF
EXPOSED TO HEAT &/OR FIRE. VAPORS CAN TRAVEL TO A SOURCE OF
IGNITION & FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PPE AS INDICATED IN EXPOSURE
CONTROLS, PERSONAL PROT SECTION. ABSORB SPILL W/INERT MATL, (E.G.,
DRY SAND OR EARTH), THEN PLACE INTO CHEMICAL WASTE CONTAINER. WEAR
APPROP PROT CLTHG TO MINIM IZE CONT W/SKIN. REMOVE ALL SOURCES OF
IGNITION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNITION.
STORE IN TIGHTLY CLOSED CONTAINERS. USE W/ADEQUATE VENTILATION.
AVOID CONTACT W/EYES, SKIN & CLOTHING.
Other Precautions:DANGER! EXTREMELY FLAMMABLE LIQUID. EMPTY CONTAINERS
RETAIN PRODUCT RESIDUE (LIQUID &/OR VAPOR), & CAN BE DANGEROUS. DO
NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL, GRIND OR EXPOSE
EMPTY CONTAINER S TO HEAT, SPARKS OR OPEN FLAMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW OSHA RESPIRATOR REGULATIONS FOUND IN 29
CFR 1910.134 OR EUROPEAN STANDARD EN 149. ALWAYS USE A NIOSH
APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:USE PROCESS ENCLOSURE, LOC EXHST VENT/OTHER ENGINEERING
CONTROLS TO CONTROL AIRBORNE LEVELS BELOW REC EXPOSURE LIMITS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . USE APPROP PROT CLTHG TO PREVENT SKIN EXPOS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING & WASH BEFORE REUSE.
Supplemental Safety and Health
EXTING MEDIA:ALCOHOL-RESIST FOAM. EFTS OF OVEREXP:INHAL. TARGET
ORGANS:KIDNEYS, CNS, LIVER, RESP SYS. FIRST AID PROC:NOT BRTHG,
GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYG. NOTES TO MD:TREAT
SYMPTOMA TICALLY & SUPPORTIVELY. EYE PROT:& FULLLENGTH FACESHIELD .
MATLS TO AVOID:CHROMYL CHLORIDE, NITROSYL (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:133F,56C
Melt/Freeze Pt:M.P/F.P Text:-140F,-95C
Vapor Pres:180
Vapor Density:2.0
Spec Gravity:0.79 (H*2O=1)
pH:7
Evaporation Rate & Reference:7.7 (N-BUTYL ACETATE=1)
Solubility in Water:SOLUBLE
Appearance and Odor:COLOURLESS LIQUID; SWEETISH ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
FORMS EXPLO MIXTS W/HYDROGEN PEROXIDE, ACETIC ACID, NITRIC ACID, NITRIC
ACID + SULFURIC ACID, CHROMIC ANHYDRIDE,(SUPDAT)
Stability Condition to Avoid:HIGH TEMPERATURES, TEMPERATURES ABOVE
220C.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT W/FEDERAL,
STATE & LOCAL REGULATIONS. RCRA WASTE NUMBER: U002 (IGNITABLE
WASTE).
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CONTINENTAL 316L
CAGE:3Y167
CAGE:3Y167
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3 DUST
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE). MFR'S CAS
NO:13463-67-1.
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:POTASSIUM SILICATE. MFR CAS NO:1317-76-1.
CAS:1312-76-1
OSHA PEL:N/K
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:FLUORSPAR; (CALCIUM FLOURIDE)
CAS:14542-23-5
OSHA PEL:2.5 MG/M3 (F) (MFR)
ACGIH TLV:2.5 MG/M3 (F) (MFR)
Ingred Name:CHROMIUM (III) OXIDE (2:3)
CAS:1308-38-9
RTECS #:GB6475000
OSHA PEL:0.05 MG/M3 (CR VI)
ACGIH TLV:0.05 MG/M3 (CR VI)
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
OSHA PEL:N/K
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUPDAT:2B. NTP 6TH ANNUAL RPT ON CARCINS, 1991:ANTIC TO BE
CARCIN. HUMAN:LUNGS, NASAL CAVITIES. CHROMIUM OXIDE: (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:NTP 6TH ANNUAL RPT ON CARCINS, 1991:KNOWN TO BE
CARCIN. HUMAN/ANIMAL:LUNG CANCER, SKIN ULCERS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:PRINTING OFFICE, WASHINGTON D.C. 20402 FOR MORE
DETAIL.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:FILTER LENS. AS A RULE OF THUMB, START W/SHADE
WHICH IS TOO DARK TO SEE WELD ZONE. THEN GO TO NEXT LTR (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:SHADE WHICH GIVES SUFFICIENT VIEW OF WELD ZONE.
PROVIDE SCREENS & FLASH GOGGS, IF NEC, TO SHIELD OTHERS.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP:ELEC SHOCK. SEE ANSI Z-49.1. AT A MIN,
RTECS #:9999999ZZ
Ingred Name:ING 19:ARM PROTECTORS, APRONS, HATS, SHOULDER PROT, AS WELL
AS DARK SUBSTANTIAL CLTHG.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:FUMES & GASES CAN BE DANGEROUS TO YOUR
HEALTH. ACUTE:SHORT-TERM OVEREXPOSURE TO WELDING FUMES MAY RESULT
IN DISCOMFORT SUCH AS: DIZZINESS, NAUSEA, OR DRYNESS OR IRRITATION
OF NOSE, THROAT OR EYES. CHR ONIC:LONG-TERM OVEREXPOSURE MAY LEAD
TOSIDEROSIS (IRON DEPOSITS IN THE LUNGS) & IS BELIEVED BY SOME
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CHROMIUM:IARC MONOGRAPHS, VOL 49, PG 49,
1990:GRP 1. NTP 6TH ANNUAL RPT ON CARCINS, 1991:KNOWN TO BE CARCIN.
(SUPDAT)
Effects of Overexposure:HLTH HAZ:INVESTIGATORS TO AFFECT PULMONARY
FUNCTION. ARC RAYS CAN INJURE EYES & BURN SKIN. ELECTRIC SHOCK CAN
KILL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:CALL FOR MEDICAL AID. EMPLOY FIRST AID TECHNIQUES RECOMMENDED
BY AMERICAN RED CROSS. INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO
FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:I
MMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES, SEEK
ASSISTANCE FROM MD . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD
.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS CAN IGNITE
COMBUSTIBLES. REFER TO ANSI 249.1 FOR FIRE PREVENTION DURING
WELDING.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS &
PRECAUTIONARY LBL ON THIS PROD. TRAIN WELDER TO KEEP HIS HEAD OUT
OF FUMES.
Other Precautions:TRAIN WELDER NOT TO TOUCH LIVE ELEC PARTS & TO
INSULATE HIMSELF FROM WORK & GROUND. SEE ANSI Z-49.1, SAFETY IN
WELDING & CUTTING, PUBLISHED BY AWS, P.O. BOX 351040, MIAMI, FL
33135 & OSHA PUBLICATION 2206 (29 CFR 1910), U.S. GOVT (ING 16)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRABLE FUME
RESPIRATOR OR NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR WHEN
WELDING IN CONFINED SPACE OR WHERE LOCAL EXHAUST OR VENTILATION
DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:USE ENOUGH VENT, LOCAL EXHAUST AT ARC, OR BOTH, TO KEEP
FUMES & GASES BELOW TLV'S IN WORKER'S BREATHING ZONE & GEN AREA.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . WEAR
HEAD, HAND & BODY PROT TO PVNT INJURY FROM RADIA, SPKS & (ING 19)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PROD:MOLYBDENUM. GASEOUS RXN PRODS MAY INCL CARBON MONOXIDE
& CARBON DIOXIDE. OZONE & NITROGEN OXIDES MAY BE FORMED BY RADIA
FROM ARC IN TIG WELDING. EXPLAN OF CARCIN:HUMAN/ANIMAL:LUNG CANC
ER, SKIN ULCERS. NICKEL:IARC MONOGRAPHSON EVALUATION OF CARCIN RISK
OF CHEMS TO MAN, VOL 49, PG 257, 1990:GRP (ING 14)
================== Physical/Chemical Properties ==================
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:REAS EXPECTED FUME CONSTITUENTS WOULD
INCL COMPLEX OXIDES OF IRON, CHROMIUM, MANGANESE, SILICON, NICKEL &
(SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FOLIC ACID INJECTION
Preparer's Name:CHRISTINA J. BARRINGTON
CAGE:EO410
CAGE:EO410
CAGE:0K706
============= Composition/Information on Ingredients =============
Ingred Name:BENZYL ALCOHOL
CAS:100-51-6
RTECS #:DN3150000
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYLENEDIAMINETETRAACETIC ACID, DISODIUM SALT
CAS:139-33-3
RTECS #:AH4375000
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Other REC Limits:NONE RECOMMENDED
Ingred Name:FOLIC ACID
CAS:59-30-3
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: 239 MG/KG INTRAVENOUS MOUSE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE, SKIN AND RESPIRATORY IRRITATION
MAY OCCUR. NOTE: THIS PRODUCT INTENDED FOR THERAPEUTIC USE ONLY
WHEN PRESCRIBED BY A PHYSICIAN.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, RESPIRATORY
IRRITATION.
Medical Cond Aggravated by Exposure:PRE-EXISITNG SKIN AND RESPIRATORY
CONDITIONS MAY BE ADVERSELY AFFECTED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE PERSON TO FRESH AIR IMMEDIATELY. GIVE
ARTIFICIAL RESPIRATION AND CPR IF REQUIRED. SEEK MEDICAL ATTENTION.
INGESTION: FLUSH MOUTH WITH WATER IMMEDIATELY. SEEK MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING IMMEDIATELY. FLUSH
AREA WITH WATER. SEEK MEDICAL ATTENTION. EYES: IMMEDIATELY FLUSH
WITH WATER FOR AT LEAST 15 MINUTES. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIE OR FOAM AS
APPRORPIATE
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND
FULL FACE-PIECE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION IT EMITS
TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RECOMMENDED PERSONAL PROTECTIVE
EQUIPMENT. USE ABSORBENT TOWELS OR BOOMS TO CLEAN-UP SPILL. WIPE
SURFACES CLEAN AND WASH WITH SOAP AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WHEN HANDLING PHARMACEUTICAL PRODUCTS,
AVOID ALL CONTACT AND INHALATION OF DUST, FUMES, MISTS AND/OR VAPOR
ASSOCIATED WITH THE PRODUCT.
Other Precautions:FOR ADVERSE DRUG REACTION INFORMATION, CALL
708-317-5937.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WITH SATISFACTORY VENTILATION, RESPIRATORY
PROTECTION NOT USUALLY REQUIRED.
Ventilation:GENERAL ROOM VENTILATION IS USUALLY SATISFACTORY, USE LOCAL
EXHAUST VENTIALTION WHEN NECESSARY.
Other Protective Equipment:DISPOSABLE GARMENTS IF DIRECT SKIN CONTACT
IS ANTICIPATED.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
POTENTIAL ADVERSE REACTIONS FROM PRESCRIBED DOSES AND OVERDOSES ARE
DESCRIBED MORE FULLY IN THE PACKAGE INSERT. OCCUPATIONL EXPOSURE
HAS NOT BEEN FULLY INVESTIGATED.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:NOT GIVEN
pH:8-11
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:SOLUBLE W/NAOH
Appearance and Odor:CLEAR, YELLOW/ORANGE SOLUTION, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXPOSURE TO LIGHT MAY CAUSE DECOMPOSITION.
Hazardous Decomposition Products:SMOKE, TOXIC FUMES OF NOX.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PCBS IN SOIL (LAB STD), AROCLOR 1016
CAGE:1R664
CAGE:1R664
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS); (POLYCHLOROBIPHENYLS)
(SARA 313) (CERCLA)
CAS:1336-36-3
RTECS #:TQ1350000
Fraction by Wt: <0.01%
OSHA PEL:N/K
ACGIH TLV:1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SOIL; (CLEAN SOIL)
Fraction by Wt: >99.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYCHLORINATED BIPHENYL (AROCLOR 1016); (AROCLOR 1016)
(SARA 313) (CERCLA)
CAS:12674-11-2
RTECS #:TQ1351000
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:PRIMARY IRRIT. IRRIT & DMGS ALL TISS.
MAY CAUSE LIVER, KIDNEY & LUNG DAMAGE. MAY CAUSE CARDIAC ARRHY, MAY
SENSIT HEART TO EPINEPHRINE. MAY CAUSE ALLERGIC DERM/CHLORACNE. MAY
CAUSE CANCER OF LIVER OR H EMATOPOEITIC SYS. SYMPS:RED, DRY SCALY
SKIN; CRACKING & WEEPING SKIN, COUGH & WHEEZING. JAUNDICE, NAUS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:POLYCHLOROBIPHENYLS:IARC MONOGRAPHS,
SUPP, VOL 7, PG 322, 1987:GROUP 2A. NTP 7TH ANNUAL RPT ON CARCINS.
1994:(SUPDAT)
Effects of Overexposure:EFTS OF OVEREXP:& VOMIT; UREMIA. MAY CAUSE
CHLORACNE. CHLOROCARB MATLS HAVE PRDCED SENSIT OF MYOCARDIUM TO
EPINEPHRINE IN LAB ANIMALS & COULD HAVE SIMILAR EFT IN HUMANS.
ADRENOMIMETICS (E.G., EPINEPHR INE) MAY BE CONTRAINDICATED EXCEPT
FOR LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY EXPOSED TO
CHLOROCARBS(SUPDAT)
Medical Cond Aggravated by Exposure:DERMATITIS, LIVER DISEASE, KIDNEY
DISEASE, ANEMIAS AND LEUKOPENIAS.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15
MINUTES, SEEK ASSISTANCE FROM MD . INHALATION:REMOVE FROM EXPOSURE.
INGESTION:GIVE SYRUP OF IPECAC 30 CC AND 180 CC (6 OZ) WATER IF SWA
LLOWED. SKIN:WASH SKIN.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY FORM CARBON MONOXIDE, PHOSGENE, AND
CARBONYL BROMIDE IN FIRE. (SIGNIFICANT ONLY IF LG QTY INVOLVED).
THERMAL DECOMPOSITION PRODS MAY INCLUDE HCL .
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. DAMPEN WITH WATER SPRAY TO
PREVENT DUST DISPERSION. CALL CLEANUP TEAM. DO NOT FLUSH TO DRAIN
OR OPEN WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:ONLY 1 AROCLOR WILL BE PRESENT IN EACH
SAMPLE. AROCLORS ARE ABSORBED TO INERT MICRO-PARTICULATE CLAY.
HANDLE WITH CARE. MATERIAL CONTAINS CARCINOGENS.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GEN VICIN OF
ARC WELDING, OPEN FLAMES/HOT SURFS. HEAT &/OR UV RADIA MAY CAUSE
FORM OF HCL &/OR PHOSGENE . AVOID BREAKAGE. USE IN AREA WHERE
SPILLS CAN BE CONTAINED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED PARTICULATE OR COMBINED
VAPOR/PARTICULATE FULL FACE RESPIRATOR OR NIOSH/MSHA APPROVED SELF
CONT/POSITIVE PRESSURE FULL FACE UNIT.
Ventilation:LOCAL EXHAUST:USE IN HOOD. SPECIAL:VENTILATE SPILLS.
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
CHEM IMPERVIOUS CLTHG IF LG AMTS USED. LAB COAT, IMPERVIOUS (SUP
DAT)
Work Hygienic Practices:USE CAREFUL LABORATORY TECHNIQUE. AVOID
CONTACT.
Supplemental Safety and Health
EFTS OF OVEREXP:. SEVERAL POLYCHLOROBIPHENYLS ARE ANIMAL POS, HUMAN
SUSPECT, CARCINS. THESE SAMPLES SHOULD BE HNDLD W/GREAT CARE. OTHER
PROT EQUIP:APRON W/SLEEVE & CLSD SHOES. EXPLAN OF CARCINS: ANTIC TO
BE CARCIN. ANIMAL:TUMORS OF LIVER, PITUITARY GLAND, LEUKEMIA.
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE GREY POWDER; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:HCL, PHOSGENE .
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . INCINERATE OR DISPOSE AS HAZARDOUS WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TANNERY LETH/VINYL 10 OZ. SPRAY, #131
CAGE:KANDW
CAGE:KANDW
CAGE:KWPRD
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM DISTILLATES; (PETROLEUM DISTALLATES)
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE & CHRONIC:MAY BE HARMFUL IF
SWALLOWED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . SKIN:WASH WITH SOAP AND WATER.
EYES:FLUSH WITH EXCESS WATER FOR AT LEAST 15 MINUTES. INHAL:REMOVE
TO FRESH AIR, ADMINISTER OXYGEN IF NECESSARY, CONTACT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:130F,54C
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CANS MAY BURST ABOVE 140F.
================== Accidental Release Measures ==================
Spill Release Procedures:BLOT WITH ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS UNDER PRESSURE. DO NOT STORE
BELOW 0C OR ABOVE 50C. DO NOT USE NEAR HEAT, SPARKS OR FLAMES.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DO NOT PUNCTURE OR
INCINERATE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH SKIN WITH SOAP AND WATER AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:210F,99C
Spec Gravity:0.99 (H*20=1)
Evaporation Rate & Reference:<1.11 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:OFF WHITE OPAQUE SOLUTION WITH CHARACTERISTIC ORDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE
(THERMAL).
==================== Disposal Considerations ====================
Waste Disposal Methods:LAND FILL AS PRESCRIBED BY FEDERAL, STATE AND
LOCAL AUTHORITIES.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:ASPHALT CEMENT,AC-20
CAGE:0EM46
CAGE:0EM46
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM ASPHALTS
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE THERMAL BURNS. SKIN:
MAY CAUSE THERMAL BURNS/HARMFUL. INHALATION: MAY CAUSE IRRITATION
OF THE UPPER RESPIRATORY TRACT. BREATHING HYDROGEN SULFIDE GAS MAY
BE HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNS, NAUSEA, IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: WASH IMMEDIATELY W/FRESH WATER. SKIN: QUICKLEY COOL
W/WATER FOR EXTENSIVE BURNS. DON'T USE SOLVENTS/THINNERS TO REMOVE
MATERIAL. IT CAN BE REMOVED W/VEGETABLE OIL/MINERAL OIL.
INHALATION: REMOVETO FRESH AIR. GIVE CPR IF NEEDED. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:425F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER SPRAY
Fire Fighting Procedures:DON'T ENTER ANY ENCLOSED/CONFINED FIRE SPACE
W/O PROPER PROTECTIVE EQUIPMENT & SCBA.
Unusual Fire/Explosion Hazard:DON'T USE PRESSURE TO EMPTY
DRUM/EXPLOSION MAY RESULT.
================== Accidental Release Measures ==================
Spill Release Procedures:ALLOW TO COOL & SOLIDIFY BEFORE PROCEEDING
W/DISPOSAL METHODS. CLEAN UP AS SOON AS POSSIBLE, OBSERVING
PRECAUTIONS IN SPECIAL PROTECTIVE INFORMATION & ON PRODUCT LABEL.
======================Handling and Storage ======================
Handling and Storage Precautions:READ & OBSERVE ALL PRECAUTIONS ON
PRODUCT LABEL. REPLACE CAP/BUNG.
Other Precautions:DON'T WELD, HEAT/DRILL CONTAINER. EMPTIED CONTAINER
STILL CONTAINS HAZARDOUS MATERIAL WHICH MAY IGNITE W/EXPLOSIVE
VIOLENCE IF HEATED SUFFICIENTLY. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF OPERATING CONDITIONS CREATE THE EXPOSURE
STANDARD, THE USE OF AN APPROVED RESPIRATOR/AIR-SUPPLIED BREATHING
EQUIPMENT IS RECOMMENDED.
Ventilation:ADEQUATE TO KEEP THE AIRBORNE CONCENTRATIONS OF THIS
MATERIAL BELOW THE EXPOSURE STANDARD.
Other Protective Equipment:PROTECTIVE CLOTHING, WASHING FACILITIES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:650-1000F
Spec Gravity:1-1.04
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK SEMI-SOLID, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:THERMAL, LIGHT
Hazardous Decomposition Products:CO2, OXIDES OF SULFUR, NITROGEN;
INCOMPLETE COMBUSTION CAN PRODUCE CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS & BURY IN AN APPROVED DUMPING AREA IAW/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PARAPLEX P-340
CAGE:FO048
CAGE:FO048
CAGE:77902
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE, MONOMER (SARA III)
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 35%
OSHA PEL:100 PPM
ACGIH TLV:S,50PPM/100STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POLYESTER RESIN
Fraction by Wt: 65%
===================== Hazards Identification =====================
Effects of Overexposure:HIGH VAPOR CONC CAN CAUSE IRRIT OF EYES & RESP
TRACT,NARCOSIS.DIRECT LIQ CONTACT (SEE OTHER PRECAUT)
======================= First Aid Measures =======================
First Aid:EYE:FLUSH IMMED W/PLENTY OF H*2O FOR @ LEAST 15 MIN,CALL
DR.SKIN:REMOVE CONTAM CLTHG PROMPTLY,WASH AFFECTED AREA W/SOAP &
H*2O.WASH CLTHG BEFORE REUSE.INHAL:MOVE TO FRESH AIR.ADMINISTER
O*2/GIVE ARTIF ICIAL RESPIRATION AS NEEDED.(SEE OTHER PRECAUTION)
===================== Fire Fighting Measures =====================
Flash Point:80F (26.7C),PMCC
Lower Limits:1.1
Upper Limits:6.1
Extinguishing Media:FOAM,CO*2,DRY CHEMICAL,H*2O SPRAY.
Fire Fighting Procedures:WEAR SCBA.USE H*2O SPRAY TO COOL FIRE-EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CNTNR MAY RUPTURE EXPLOSIVELY DUE
TO POLYMERIZATION.VAP MAY TRAVEL TO IGNIT SOURCE,FLASHBACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNIT SOURCE.EVACUATE SPILL AREA &
WEAR APPROVED RESPIRATORS.DIKE SPILL W/INERT
MATERIAL(SAND,EARTH,ETC.) & TRANSFER LIQ & SOLID TO SEPARATE CNTNRS
FOR RECOVERY/DISPOSAL.KEEP SPILL OUT OF AL L SEWERS & OPEN BODIES
OF H*2O.
======================Handling and Storage ======================
Handling and Storage Precautions:INDOOR STORAGE OF FLAMMABLE LIQ SHOULD
BE LIMITED TO APPROVED AREAS EQUIPPED W/OVERHEAD SPRINKLERS.GROUND
CONTAINERS WHEN POURING/TRANSFERRING.
Other Precautions:EMER & FIRST AID PROC: INGEST:DO NOT INDUCE
VOMITING.CALL PHYSICIAN IMMEDIATELY. OVEREXP EFT:W/EYES CAUSES
IRRIT.PRLNG/RPTD SKIN CONTACT CAUSES IRRIT DUE TO DEFATTING ACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR SUITABLE FOR
VAPOR CONC ENCOUNTERED.
Ventilation:EXPLOSION-PROOF MECHANICAL EXHAUST VENT @ POINT OF
OPERATION
Other Protective Equipment:IMPERVIOUS APRON,EYEWASH FOUNTAIN,EMERGENCY
SHOWER.
Supplemental Safety and Health
% VOLATILE BY WT:35 (STYRENE). VALVES FOR VAPOR PRESS,VAPOR DENSITY,LEL
& VEL FOR STYRENE. PRODUCT DISCONTINUED IN 1977. DATE OF PREP
8-1-77.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:295F (145C)
Vapor Pres:6.4
Vapor Density:3.6
Spec Gravity:1.118
Evaporation Rate & Reference:SLOWER THAN BUAC.
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR PALE YELLOW LIQUID.STYRENE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING/REDUCING AGENTS
Stability Condition to Avoid:IGNITION SOURCES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD OXIDES
OF CARBON,ACRID FUMES
Conditions to Avoid Polymerization:ELEVATED TEMPERATURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN FEDERAL,STATE & LOCAL REGULATIONS.
INCINERATE LIQUID IN APPROVED EQUIPMENT. LANDFILL CONTAMINATED
DIKING MATERIAL ACCORDING TO CURRENT REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-286-5297
Product ID: DIESEL FUEL NO.2 GRADE
Cage: 0GYU1
=======================================================
Contractor Summary
=======================================================
Cage: 0GYU1
Cage: 0A777
=======================================================
Item Description Information
=======================================================
Item Name: DIESEL FUEL
Specification Number: VV-F-800
Type/Grade/Class: GRADE DF-2
Unit of Issue: DR
Quantitative Expression: 00000000055GL
UI Container Qty: 0
=======================================================
Ingredients
=======================================================
Cas: 68476-30-2
% Wt: UNKNOWN
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: ORAL LD50 (RAT) IS > 5 ML/KG
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE-NOT EXPECTED TO CAUSE PROLONGED EYE IRRITATION.
SKIN-MODERATE SKIN IRRITANT. INHALATION-PROLONGED BREATHING OF VAPORS CAN
CAUSE CENTRAL NERVOUS SYSTEM EFFECTS. INGESTION-IF SWALLOWED, THIS SUBSTAN CE
IS CONSIDERED PRACTICALLY NON-TOXIC TO INTERNAL ORGANS.
Explanation Of Carcinogenicity: NOT CARCINOGENIC.
Signs And Symptions Of Overexposure: SKIN-PAIN OR A FEELING OF HEAT,
DISCOLORATION, SWELLING AND BLISTERING. INHALATION-HEADACHE, DIZZINESS, LOSS
OF APPETITE, WEAKNESS AND LOSS OF COORDINATION. INGESTION-ASPIRATION HAZARD.
ONCE IN THE LU NGS, THE SUBSTANCE IS VERY DIFFICULT TOREMOVE & CAN CAUSE
SEVERE INJURY & DEATH.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE-NO FIRST AID REQUIRED. FLUSH EYES WITH FRESH WATER. SKIN-WASH
SKIN THOROUGHLY WITH SOAP & WATER. INHALATION-MOVE THE PERSON TO FRESH
AIR. SEE DOCTOR. INGESTION-GIVE ATER OR MILK TO DRINK & CALL FO R MEDICAL
ADVICE. DO NOT MAKE PERSON VOMIT UNLESS DIRECTED BY MEDICAL PERSONNEL. TAKE
PERSON TO NEAREST MEDICAL EMERGENCY TREATMENT CENTER OR HOSPITAL.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ELIMINATE ALL SOURCES OF IGNITION. CLEANUP SPILL
IMMEDIATELY. THIS MATERIAL IS CONSIDERED TO BE A WATER POLLUTANT. RELEASE OF
THIS PRODUCT SHOULD BE PREVENTED FROM CONTAMINATING SOIL & WATER &
FROM EN TERING DRAINAGE & SEWER SYSTEMS.
Waste Disposal Methods: CLEAN UP SPILL USING APPROPRIATE TECHNIQUE SUCH AS
SORBENT MATERIAL OR PUMPING. WHERE FEASIBLE & APPROPIATE, REMOVE
CONTAMINATED SOIL. PLACE CONTAMINATED MATERIAL IN DISPOSABLE CONTAINERS &
DISPOSE OF IN A MANNER CONSISTENT WITH APPLICABLEREGULATION
Handling And Storage Precautions: DO NOT USE OR STORE NEAR FLAME, SPARKS OR HOT
SURFACES. USE ONLY IN WELL VENTILATED AREA. KEEP CONTAINER CLOSED.
Other Precautions: DO NOT WELD, HEAT OR DRILL CONTAINER. REPLACE CAP OR BUNG.
EMPTIES CONTAINER STILL CONTAINS HAZARDOUS OR EXPLOSIVE VAPOR OR LIQUID.
CAUTION! DO NOT USE PRESSURE TO EMPTY DRUM OR DRUM MAY RUPTURE WITH
EXPLOSIVE FORCE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 130F,54C
Autoignition Temp Text: NDA
Lower Limits: 0.6
Upper Limits: 4.7
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, AND WATER FOG.
Fire Fighting Procedures: FOR FIRES INVOLVING THIS MATERIAL, DO NOT ENTER ANY
ENCLOSED OR CONFINED FIRE SPACE WITHOUT PROPER PROTECTIVE EQUIPMENT
(SELF-CONTAINED BREATHING APPARATUS).
Unusual Fire/Explosion Hazard: LIQUID EVAPORATES & FORMS VAPOR WHICH CAN
CATCH FIRE & BURN WITH EXPLOSIVE VIOLENCE. INVISIBLE VAPOR SPREADS EASILY
& CAN BE SET ON FIRE BY MANY SOURCES.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NO SPECIAL RESPIRATORY PROTECTION IS NORMALLY REQUIRED.
HOWEVER, IF OPERATING CONDITIONS CREATE HIGH AIRBORNE CONCENTRATIONS, THE USE
OF AN APRROVED RESPIRATOR IS RECOMMENDED.
Ventilation: USE THIS MATERIAL ONLY IN WELL VENTILATED AREAS.
Other Protective Equipment: AVOID CONTACT WITH SKIN OR CLOTHING. SKIN CONTACT
SHOULD BE MINIMIZED BY WEARING PROTECTIVE CLOTHING.
Work Hygienic Practices: DISCARD CONTAMINATED NON-WATER PROOF SHOES AND BOOTS.
WASH CONTAMINATED CLOTHING.
Supplemental Safety and Health: NOTE TP PHYSICIAN: INGESTION OF THIS PRODUCT OR
SUBSEQUENT VOMITING CAN RESULT IN ASPIRATION OF LIGHT HYDROCARBON LIQUID,
WHICH CAN CAUSE PNEUMONITIS.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: F4
B.P. Text: 304-574F
Vapor Pres: 0.40
Vapor Density: 4.7
Spec Gravity: 0.84-0.89
Viscosity: 1.9-4.1 CST
Evaporation Rate & Reference: 0.04 BUTYL ACETATE=1
Solubility in Water: INSOLUBLE
Appearance and Odor: WATER WHITE TO CLEAR YELLOW OILY LIQUID WITH MILD
PETROLEUM ODOR.
Percent Volatiles by Volume: NEGL
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: FIRE HAZARD IS GREATER AS LIQUID TEMPERATURES
RISES ABOVE 85F.
Materials To Avoid: MAY REACT WITH STRONG OXIDIZING AGENTS, SUCH AS CHLORATES,
NITRATES, PEROXIDES, ETC.
Hazardous Decomposition Products: NORMAL COMBUSTION FORMS CARBON DIOXIDE &
WATER VAPOR; INCOMPLETE COMBUSTION CAN PRODUCE CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 67102
Product ID: DIESEL FUEL NO.2 GRADE
Review Date: 08/12/1993
Net Unit Weight: 384.7 LBS
AF MMAC Code: NR
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: DR
Container QTY: 0
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: GTF
DOT Proper Shipping Name: GAS OIL OR DIESEL FUEL OR HEATING OIL, LIGHT
Hazard Class: 3
UN ID Num: UN1202
DOT Packaging Group: III
Label: FLAMMABLE LIQUID
Special Provision: B1,T7,T30
Packaging Exception: 150
Non Bulk Pack: 203
Bulk Pack: 242
Max Qty Pass: 60 L
Max Qty Cargo: 220 L
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN TX
IATA UN ID Num: 1202
IATA Proper Shipping Name: GAS OIL
IATA UN Class: 3
IATA Label: FLAMMABLE LIQUID
UN Packing Group: III
Packing Note Passenger: 309
Max Quant Pass: 60L
Max Quant Cargo: 220L
Packaging Note Cargo: 310
Exceptions: A3
=======================================================
Detail AFI Information
=======================================================
AFI PSN TX
AFI Proper Shipping Name: GAS OIL OR DIESEL FUEL OR HEATING OIL, LIGHT
AFI Hazard Class: 3
AFI UN ID NUM: UN1202
AFI Packing Group: III
Special Provisions: P5
Back Pack Reference: A7.3
=======================================================
HAZCOM Label
=======================================================
Product ID: DIESEL FUEL NO.2 GRADE
Cage: 0GYU1
Company Name: LOUIS DREYFUS ENERGY CORP
Street: 8800 ROSWELL RD SUITE 200
Zipcode: 30350
Label Required IND: Y
Date Of Label Review: 08/12/1993
Status Code: C
Label Date: 08/12/1993
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: IN CASE OF SPILL: ELIMINATE ALL SOURCES OF IGNITION.
CLEANUP SPILL IMMEDIATELY. THIS MATERIAL IS CONSIDERED TO BE A WATER
POLLUTANT. RELEASE OF THIS PRODUCT SHOULD BE PREVENTED FROM CONTAMINATING
SOIL& WATER & FROM ENTERING DRAINAGE & SEWER SYSTEMS. FIRST
AID: EYE-NO FIRST AID REQUIRED. FLUSH EYES WITH FRESH WATER. SKIN-WASH SKIN
THOROUGHLY WITH SOAP & WATER. INHALATION-MOVE THE PERSON TO FRESH A IR.
SEE DOCTOR. INGESTION-GIVE ATER OR MILK TO DRINK & CALL FOR MEDICAL
ADVICE.DO NOT MAKE PERSON VOMIT UNLESS DIRECTED BY MEDICAL PERSONNEL. TAKE
PERSON TO NEAREST MEDICAL EMERGENCY TREATMENT CENTEROR HOSPITAL.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:882 7602 RP X-OMAT DEVELOPER REPLENISHER-WORKING SOLUTION
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 85 - 90%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:GLUTARALDEHYDE BIS(SODIUM BISULFITE)
CAS:7420-89-5
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN. ACUTE-
EYES/SKIN: CAUSES IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION.
INHALATION:LOW HAZARD FOR RECOMMENDED HANDLING. ORAL:EXPECTED TO BE
A LOW INGESTION HAZARD. MAY CAUSE I RRITATION OF THE
GASTROINTESTINAL TRACT. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, ALLERGIC SKIN REACTION
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING SKIN
DISORDERS MAY BE MORE SUCCEPTIBLE TO THE EFFECTS FROM EXPOSURE TO
THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. EYES:FLUSH WITH WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN.
SKIN:WASH WITH SOAP & WATER. ORAL:IF CONSCIOUS, DRINK 1-2 GLASSES
OF WATE R. SEEK MEDICAL ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO
AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNT OF WATER IF
PERMITTED. OTHERWISE, ABSORB SPILL WITH INERT MATERIAL SUCH AS
VERMICULITE. PLACE IN A CONTAINER FOR DISPOSAL. CLEAN AREA
THOROUGHLY TO REMOVE RESIDUAL CON TAMINATION. PREVENT RUNOFF FROM
ENTERING SEWERS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM STRONG ACIDS. KEEP
CONTAINER CLOSED. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID CONTACT WITH EYES, SKIN AND CLOTHING. USE WITH
ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING. THE ROUTINE
USE OF A NONALKALINE (ACID) TYPE OF HAND CLEANER AND REGULAR
CLEANING OF WORKING SURFACES WILL MINIMIZE SKIN REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE WASH STATION, QUICK DRENCH SHOWER AND
IMPERVIOUS CLOTHING
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
ECOLOGICAL INFORMATION:A MODERATE BIOCHEMICAL OXYGEN DEMAND, A HIGH
POTENTIAL TO AFFECT AQUATIC ORGANISMS. AFTER DILUTION WITH WATER,
FOLLOWED BY WASTE TREATMENT, IT IS NOT EXPECTED TO CAUSE ADVERSE E
NVIRONMENT EFFECTS.
================== Physical/Chemical Properties ==================
HCC:B3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18 @ 68F
Vapor Density:0.6
Spec Gravity:1.077
pH:10.3
Viscosity:NOT RELEVANT
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW LIQUID - NO ODOR
Percent Volatiles by Volume:88
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:SULFUR DIOXIDE MAY BE FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE AMOUNT
OF WATER IF ALLOWED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FORMULA 254 CLEAN ALL DETERGENT
CAGE:0BUA7
CAGE:1CD46
CAGE:0BUA7
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 23%
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DIPHOSPHORIC ACID, TETRAPOTASSIUM SALT; (TETRAPOTASSIUM
PYROPHOSPHATE)
CAS:7320-34-5
RTECS #:JL6735000
Fraction by Wt: 12%
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
Fraction by Wt: 19%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: MISTS ARE IRRITATING TO
MUCOUS MEMBRANES. INGEST: CAUSES BURNING TO MOUTH, THROAT, STOMACH
AND POSSIBLE ULCERATION. EYE: CORROSIVE TO EYES. SKIN: SEVERE
IRRITANT, REDDENING OF SKIN, SKIN DAMAGE CAN OCCUR.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SKIN PROBLEMS.
======================= First Aid Measures =======================
First Aid:INGEST: GET MED HELP. WHILE WAITING FOR HELP, GET VICTIM TO
DRINK LARGE AMOUNTS OF MILK OR GELATIN; IF THESE ARE NOT AVAILABLE
GIVE LARGE AMOUNTS OF WATER, IF VICTIM IS CONSCIOUS. DO NOT INDUCE
VOMITI NG. INHAL: TAKE TO FRESH AIR. EYE: IMMED FLUSH WITH LOTS OF
WATER FOR AT LEAST 15 MIN. GET MED HELP. SKIN: WASH WELL WITH
WATER. DO NOT REUSE CONTAMINATED CLOTHING UNTIL THEY HAVE BEEN
WASHED.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:WATER SPRAY, CO*2.
Fire Fighting Procedures:NONE. WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTACT WITH SOFT METALS MAY RELEASE
HYDROGEN GAS WHICH IS COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:SML SPILLS:DILUTE & FLUSH TO DRAIN. LRG
SPILLS:DAM AREA TO PVNT RUN OFF TO OPEN H*2O. NEUT W/MILD ACIDS
UNDER WELL VENT CNDTNS & THEN, AFTER CNTCTG LOC SEWER AUTHORITIES &
WITH PERMISSION, SEWER @ A R ATE THAT IS ALLOWED,/PUMP INTO APPROP
(SUPP DATA)
Neutralizing Agent:MILD ACIDS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP THIS AND ALL CHEMICALS OUT OF
REACH OF CHILDREN. DO NOT SPLASH INTO EYES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL PROC: CONTAINER FOR TRANSPORTING TO APPROVED DISPOSAL FACILITY.
================== Physical/Chemical Properties ==================
HCC:C2
Spec Gravity:1.26
pH:13.3
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR BLUE LIQUID/MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, CORROSIVE TO SOFT METALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CONTACT WITH STRONG ACIDS CAN RELEASE
HYDROGEN GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: C-5A ANTISEIZE, ANTI-SEIZE LUBRICANT, 125
Cage: 05972
=======================================================
Contractor Summary
=======================================================
Cage: 05972
Cage: SO010
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NORMALLY REQUIRED UNDER GENERAL VENT. IF EXPOSURE
LEVELS ARE UNKNOWN, IF LEVELS EXCEED TLV/PEL, OR IF EFFECTS OCCUR, USE NIOSH
APPROVED DUST/MIST RESPIRATOR I/A/W WITH APPLICABLE HEALTH & SAFETY
REGULATIONS & MFR'S RECOMMENDATIONS. USE NIOSH APPROVED DUST/MIST
RESPIRATOR WHEN GRINDING OR MACHINING COATING OR COATED ITEMS.
Ventilation: GENERAL VENTILATION USUALLY ADEQUATE.
Other Protective Equipment: EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N). CLEAN CLOTHING TO COVER SKIN.
Work Hygienic Practices: WASH HANDS BEFORE EATING.
Supplemental Safety and Health: EFTS OF OVEREXP:DISCOLORATION OF SKIN &
HAIR. REFER TO PROTECTIVE EQUIPMENT SECTION FOR APPROPRIATE PROTECTIVE
MEASURES. PHYSICAL DATA: ODOR THRESHOLD: NO DATA. COEFFICIENT OF WATER/OIL
DISTRIBUTION: NOT APPLICABLE.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: >287.8C, 550.F
B.P. Text: 550F - 4215F
Vapor Density: HVR/AIR
Spec Gravity: 1.3017
Viscosity: HIGH
Evaporation Rate & Reference: SLOWER THAN BUTYL ACETATE
Solubility in Water: INSOLUBLE
Appearance and Odor: COPPER COLORED PASTE; SLIGHT PETROLEUM ODOR.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: NO PRODUCT OR COMPONENT TOXICOLOGICAL INFORMATION IS
AVAILABLE.
=======================================================
Ecological Information
=======================================================
Ecological: ECOLOGICAL TEST DATA: NO INFORMATION.
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: CERCLA - SARA HAZARD CATEGORY: THIS PRODUCT HAS
BEEN REVIEWED & IS CONSIDERED, UNDER APPLICABLE DEFINITIONS, TO MEET
FOLLOWING CATEGORIES: IMMEDIATE HEALTH HAZARD, CHRONIC HEALTH HAZARD. SARA
SECTION 313: THIS PRODUCT CONTAINS FOLLOWING SUBSTANCES SUBJECT TO REPORTING
REQUIREMENTS OF SECTION 313 & 40 CFR PART 372: COPPER - CAS $7440-50-8 -
WT = <25%.
Federal Regulatory Information: OSHA: HAZARDOUS BY DEFINITION OF HAZARD
COMMUNICATION STANDARD (29 CFR 1910.1200). TOXIC SUBSTANCES CONTROL ACT:
CHEMICAL SUBSTANCES IN THIS PRODUCT ARE ON TSCA SECTION 8 INVENTORY. CANADIAN
W: TH IS MSDS HAS BEEN PREPARED IN COMPLIANCE W/CONTROLLED PRODUCT
REGULATIONS EXCEPT FOR USE OF THE 16 HEADINGS. CANADIAN W CLASS: D2B, D2A.
State Regulatory Information: NEW JERSEY RIGHT-TO-KNOW: FOLLOWING MATERIALS ARE
NON-HAZARDOUS, BUT ARE AMONG TOP FIVE COMPONENTS IN THIS PRODUCT: FATTY
ACIDS, TALLOW, CALCIUM SALTS - CAS #64755-01-7. PENNSYLVANIA RIGHT-TO-KNOW:
FO LLOWING NON-HAZARDOUS INGREDIENTS ARE PRESENT IN PRODUCT AT >3%: FATTY
ACIDS, TALLOW, CALCIUM SALTS - CAS #64755-01-7 & HYDROTREATED HEAVY
PARAFFINIC DISTILLATE - CAS #64742-54-7. CALIFORNIA PROPOSIT ION 65: WARNING:
CHEMICAL(S) NOTED BELOW & CONTAINED IN THIS PRODUCT, ARE KNOWN TO STATE
OF CALIFORN IA TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM:
NONE KNOWN.
=======================================================
Other Information
=======================================================
Other Information: PLEASE CONTACT LOCTITE CORPORATION QUALITY DEPARTMENT FOR
ASSISTANCE & RECOMMENDATIONS ON SPECIFICATIONS FOR THIS PRODUCT - ROCKY
HILL, CT - FAX: 860-571-5473.
=======================================================
HAZCOM Label
=======================================================
Product ID: C-5A ANTISEIZE, ANTI-SEIZE LUBRICANT, 125
Cage: 05972
Company Name: LOCTITE CORPORATION
Street: 1001 TROUT BROOK CROSSING
Zipcode: 06067-3910
Label Required IND: Y
Date Of Label Review: 08/27/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: ELEVATED TEMPS MAY CAUSE IRRIT OF EYES &
RESP TRACT. EYE:SLIGHTLY IRRIT. DOES NOT INJURE TISS. SKIN:PRLNG/RPTD CONT
MAY CAUSE IRRIT. INHAL:INHAL OF DUST AT LEVELS ABOVE RELS MAY CAUSE ,ETALLIC/
SWEET TASTE, IRRIT OF PHARYNX & POSS ULCER W/PERFORATION OF NASAL SEPTUM.
INGEST:MOD TOX, IRRIT TO MOUTH, THROAT & STOM, W/NAUS. CHRONIC: CANCER
HAZ. CONTAINS SILICA, CRYSTALLINE-QUARTS WHICH IS LISTD AS A HUMAN LUNG
CARCIN (FP N). RPTD & PRLNG INHAL OF GRAPHITE/CARBON DUSTS MAY CAUSE PULM
FIBROSIS, EMPHYSEMA & PNEUM. INHAL OF FREE SILICA MAY CAUSE
SILICOSIS/DELAYED LUNG INJURY. MAY CAUSE METAL-FU ME FEVER. DISCOLORATION OF
THE SKIN & HAIR.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:22519, TKN INDICATOR SOLUTION
CAGE:4T252
CAGE:4T252
============= Composition/Information on Ingredients =============
Ingred Name:PROPIONIC ACID
CAS:79-09-4
RTECS #:UE5950000
Fraction by Wt: <3%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NON HAZARDOUS INGREDIENTS
Fraction by Wt: <1%
Ingred Name:WATER (DEMINERALIZED)
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: <100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT MAY BE IRRITATING TO EYES
AND SKIN. ACUTE TOXICITY:SLIGHTLY TOXIC. CHRONIC TOXICITY:NOT
DETERMINED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE REPORTED.
======================= First Aid Measures =======================
First Aid:EYE:IMMEDIATELY FLUSH W/WATER FOR AT LEAST 15 MINUTES. CALL
MD. SKIN:FLUSH W/PLENTY OF WATER. INGEST:GIVE LARGE QUANTITIES OF
WATER OR MILK. CALL MD IMMEDIATELY. INHAL:REMOVE TO FRESH AIR.
SUPPORT BRE ATHING (GIVE O*2/ARTF RESP) .
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE W/WATER. POUR DOWN DRAIN W/EXCESS
WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TIGHTLY CLOSED. AVOID CONTACT
W/EYES, SKIN & CLOTHING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:ADEQUATE VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1
pH:5
Evaporation Rate & Reference:0.7
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, PURPLE LIQUID, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HEAT, FLAMES.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W ALL FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL, ALKYD, GLOSS LO VOC CT, GREEN 14672, ID 774452
Preparer's Name:W A ELLISON
CAGE:61196
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (SOLVENT) (VAPOR PRESSURE 10 MM HG @ 20C)
(LFL 1.7; UFL 7.6)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM;STEL 200 PPM
ACGIH TLV:150 PPM;STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE (SOLVENT) (SARA III) (VAPOR PRESSURE 5 MM HG @ 20C)
(LFL 1.0; UFL 7.0)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT NAPHTHA, LIGHT AROMATIC (SOLVENT)
CAS:64742-95-6
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA III) (SOLVENT)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TITANIUM DIOXIDE (PIGMENT)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:SILICA, AMORPHOUS HYDRATED (PIGMENT)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:TRIMETHYL BENZENE
CAS:25551-13-7
RTECS #:DC3220000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM; 125 MG/M3
ACGIH TLV:25 PPM; 125 MG/M3
Ingred Name:VOC: 2.97 LB/GAL LESS WATER & NEGLIGIBLY PHOTOCHEMICALLY
REACTIVE MATERIALS; 356 G/L LESS WATER; CALCULATED
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INGESTION: GASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING. ASPIRATION INTO LUNG MAY CAUSE CHEM
PNEUMONITIS (CAN BE FATAL). INHALATION: NOSE OR THROAT IRRITATION.
ACUTE CENTRAL NERVOUS SYSTEM DEPRESSION (HEADACHES, DIZZINESS,
NAUSEA, CONFUSION). EYE: SEVERE IRRITATION & CORNEAL DAMAGE. SKIN:
DEFATTING & SKIN IRRITATION.
Effects of Overexposure:CHRONIC: LIVER, KIDNEY AND BLOOD INJURY.
PROLONGED & REPEATED OVEREXPOSURE ASSOCIATED WITH PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING PRODUCT MAY BE HARMFUL OR FATAL.
======================= First Aid Measures =======================
First Aid:INGEST:DONT INDUCE VOMITING. CALL POISON CTR/EMERG ROOM/DR
IMMED. INHAL:REMOVE TO FRESH AIR IMMED. IF BREATHING STOPPED, GIVE
ARTIF RESPRTION. KEEP WARM & QUIET. GET MED AID IMMED. EYE:FLUSH
W/WATER 1 5 MIN, LIFTING EYELIDS. GET MED AID. SKIN:REMOVE CONTAM
CLOTHES. WASH AFFECTED AREA W/SOAP & WATER. GET MED AID IF IRRIT
PERSISTS. NOTE TO DR:DIRECT TREATMENT AT CLINICAL CONDITION &
SYMPTOM CONTROL.
===================== Fire Fighting Measures =====================
Flash Point:72.0F,22.2C
Autoignition Temp:Autoignition Temp Text:572 F
Lower Limits:1.0
Upper Limits:7.6
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CO2, DRY CHEMICAL,
ALCOHOL FOAM) FOR FLAMMABLE LIQ. POLYMER FOAM PREFERRED FOR LARGE
FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE TO COOL EXPOSED
CONTAINERS (FOG NOZZLES PREFERRED) TO PREVENT PRESSURE BUILDUP,
AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO HEAT.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY BE HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT. GET MEDICAL AID. FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RSPRTR,EYE,HAND,BODY PROTECTN. KEEP
SPECTATORS AWAY. ELIMINATE IGNIT SOURCES. DIKE & CONTAIN W/INERT
MAT'L (SAND/EARTH/ETC). TRANSFER LIQ/USED ABSORBENT TO COVERED
METAL CONTAINER. USE NON-SPARKI NG TOOL. PREVENT SEWER, GROUNDWATER
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 115 F. STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29 CFR 1910.106. DO NOT TAKE
INTERNALLY. DO NOT BREATHE SANDING DUST.
Other Precautions:CLOSE CONTAINER AFTER EACH USE. DO NOT WASH & REUSE
EMPTY CONTAINER FOR ANY PURPOSE. GROUND & BOND CONTAINERS TO
RECEIVING CONTAINER. DO NOT WELD, BRAZE, OR CUT ON EMPTY CONTAINER.
NEVER USE PRESSURETO EMPTY. DRUM IS NOT A PRESSURE VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTD,MAY NOT REQ RSPRTR.IN RESTRICTD
VENT,NIOSH CHEM CARTRIDGE RSPRTR MAY BE REQ'D.SPRAYNG,MECHAN
PREFILTER MAY ALSO BE REQ'D.CONFIND AREAS,USE AIR SUPPLD RSPRTR.SEE
OSHA 29CFR1910.134"RESP PROTEC T"&"RESP PROTECT-MANUAL &
GUIDELINE"AIHA
Ventilation:LOCAL EXHAUST VENT TO KEEP BELOW TLV. REMOVE DECOMPOSITION
PRODUCT. SEE "INDUST VENT-MANUAL RECOMMENDED PRACTICES" ACGIH
Other Protective Equipment:EYEWASH FACILITY, SAFETY SHOWER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:165 TO 355F
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Decomp Temp:Decomp Text:1832F,1000C
Vapor Pres:10 @ 68F
Vapor Density:> AIR
Spec Gravity:1.2
pH:4-7
Viscosity:67 - 77 KU
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:40
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F) AND SOURCES
OF IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE & CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, &
LOCAL LAWS OR REGULATIONS. THIS PRODUCT, IF DISCARDED DIRECTLY,
WOULD BE CLASSIFIED A HAZARDOUS WASTE BASED ON ITS IGNITABILITY
CHARACTERISTIC (FLASH POINT 140F OR LESS). PROPER RCRA
CLASSIFICATION: D001.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CESIUM CHLORIDE, 813060
CAGE:IO030
CAGE:30060
CAGE:IO030
============= Composition/Information on Ingredients =============
Ingred Name:CESIUM CHLORIDE
CAS:7647-17-8
RTECS #:FK9625000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC:MODERATE ORAL TOXICITY.
CAN CAUSE EYE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING. RINSE LIBERALLY WITH WATER
FOR A CONSIDERABLE PERIOD. INGEST:IF WITHIN 15 MINUTES AFTER
OCCURENCE, MAKE PATIENT DRINK 1 OR 2 GLASSES OF WATER. EYES:RINSE
LIBERALLY W ITH WATER FOR AT LEAST 15 MINUTES. INHAL:TAKE THE
PATIENT INTO THE FRESH AIR AND ALLOW TO REST.
===================== Fire Fighting Measures =====================
Flash Point:NOT AVAILABLE
Extinguishing Media:USE EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP INTO SUITABLE CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:2377F,1303C
Melt/Freeze Pt:M.P/F.P Text:1195F,646C
Spec Gravity:3.99
Solubility in Water:SOLUBLE
Appearance and Odor:POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BF*3
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF C1-
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR LANDFILL AS COMPLIES WITH FEDERAL,
STATE AND LOCAL LAWS.
| 1 | gloves_mandatory |
=======================================================
Product ID: ABRASIVE CUT OFF WHEELS, 811-978-010
Cage: 94174
Resp. Party Other MSDS No.: 02430
=======================================================
Contractor Summary
=======================================================
Cage: 94174
=======================================================
Ingredients
=======================================================
Cas: 1344-28-1
RTECS #: BD1200000
Percent by Wt: 90.
Other REC Limits: N/K (FP N)
OSHA PEL: 15 MG/M3
OSHA STEL: N/K (FP N)
ACGIH TLV: 10 MG/M3
ACGIH STEL: N/K (FP N)
------------------------------
Cas: 7782-41-4
RTECS #: LM6475000
< Wt: 5.
Other REC Limits: N/K (FP N)
OSHA PEL: 0.2 MG/M3;0.1 PPM
OSHA STEL: N/K (FP N)
ACGIH TLV: 1.6 MG/M3;1 PPM
ACGIH STEL: 3.1 MG/M3;2 PPM
EPA Rpt Qty: 10 LBS
DOT Rpt Qty: 10 LBS
------------------------------
Cas: 1305-78-8
RTECS #: EW3100000
< Wt: 3.
Other REC Limits: N/K (FP N)
OSHA PEL: 5 MG/M3
OSHA STEL: N/K (FP N)
ACGIH TLV: 2 MG/M3
ACGIH STEL: N/K (FP N)
------------------------------
RTECS #: LK3651000
< Wt: 5.
Other REC Limits: N/K (FP N)
OSHA PEL: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
ACGIH STEL: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE: EYES: DUST MAY IRRITATE. SKIN: SOME MAY EXPERIENCE
IRRITATION. INHALATION: COUGHING, SHORTNESS OF BREATH. INGESTION: NO KNOWN
ADVERSE EFFECTS, BUT NOT RECOMMENDED. CHRONIC: PROLONGED EXPOSURE M AY AFFECT
LUNG FUNCTION.
Explanation Of Carcinogenicity: FIBROUS GLASS: IARC MONOGRAPHS, VOLUME43, PAGE
152, 1988: GROUP 2B.ANIMAL: BLOOD.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: PERSONS WITH CHRONIC RESPIRATORY OR
DERMATOLOGICAL DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.
First Aid: EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH EXPOSED
AREA WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: CONTACT
A PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SMALL/LARGE SPILL: SWEEP UP AND COLLECT FOR DISPOSAL.
Waste Disposal Methods: RECYCLE OR DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE
AND LOCAL REGULATIONS.
Handling And Storage Precautions: NO SPECIAL PRECAUTIONS NEEDED FOR HANDLING.
KEEP CONTAINER CLOSED WHEN STORED.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Lower Limits: NONE
Upper Limits: NONE
Extinguishing Media: USE AGENT APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures: NO SPECIAL INSTRUCTIONS. WEAR NIOSH APPROVED SCBA AND
FULL PROTECTIVE EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED RESPIRATOR IF EXPOSURE LIMITS EXCEEDED.
Ventilation: MECHANICAL OR LOCAL EXHAUST VENTILATION RECOMMENDED.
Other Protective Equipment: EMERGENCY EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 2.50
Solubility in Water: INSOLUBLE
Appearance and Odor: BROWN TO BLACK SOLID WITH NO ODOR.
Percent Volatiles by Volume: 0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: NOT AVAILABLE.
Hazardous Decomposition Products: NONE.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
Toxicological Information: NONE REPORTED.
=======================================================
Ecological Information
=======================================================
Ecological: NOT AVAILABLE.
=======================================================
=======================================================
Transport Information: U.S.A. DOT: NOT REGULATED.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SECTION 302 EXTREMELY HAZARDOUS SUBSTANCES: NONE.
SECTION 311/312 HAZARDOUS CATEGORIES: ACUTE, CHRONIC. SECTION 313 TOXIC
CHEMICALS: ALUMINUM OXIDE (FIBROUS FORMS ONLY).
Federal Regulatory Information: TSCA STATUS: ON TOXIC SUBSTANCE CONTROL
INVENTORY. CERCLA REPORTABLE QUANTITY: NONE. RCRA STATUS: NOT REGULATED.
=======================================================
Other Information
=======================================================
Other Information: HAZARD INDEX: (0-4,4=EXTREME): HEALTH: 1; FIRE:0;
REACTIVITY: 0.
=======================================================
HAZCOM Label
=======================================================
Product ID: ABRASIVE CUT OFF WHEELS, 811-978-010
Cage: 94174
Company Name: LECO CORPORATION
Street: 3000 LAKEVIEW AVE.
Zipcode: 49085-2396
Label Required IND: Y
Date Of Label Review: 06/09/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYES: DUST MAY IRRITATE. SKIN: SOME MAY
EXPERIENCE IRRITATION. INHALATION: COUGHING, SHORTNESS OF BREATH. INGESTION:
NO KNOWN ADVERSE EFFECTS, BUT NOT RECOMMENDED. CHRONIC: CANCER HAZARD. CONTA
INS FIBROUS GLASS WHICH IS LISTED AS A LUNG CARCINOGEN (FP N). PROLONGED
EXPOSURE MAY AFFECT LUNG FUNCTION.
=======================================================
| 1 | gloves_mandatory |
Subsets and Splits
No saved queries yet
Save your SQL queries to embed, download, and access them later. Queries will appear here once saved.