text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:ALKYD EGGSHELL 25-
Preparer's Name:THOMAS E. MAREK
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT; (MINERAL SPIRITS). VP:2.
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 29.3%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 3.2-3.6 LBS/GAL.
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:CAN CAUSE SEVERE IRRITATION,
REDNESS, TEARING, BLURRED VISION. SKIN:PROLONGED OR REPEATED
CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS.
INHAL:EXCESSIVE INHALATION OF VAPORS CAN CA USE NASAL & RESPIRATORY
IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
POSSIBLE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:UNCONSCIOUSNESS & EVEN ASPHYXIATION.
INGEST:CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING &
DIARRHEA. ASPIRATION INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS
WHICH CAN BE FATAL.
Medical Cond Aggravated by Exposure:NO KNOWN.
======================= First Aid Measures =======================
First Aid:SKIN:THORO WASH EXPOS AREA W/SOAP & WATER. REMOVE CONTAM
CLTHG. LAUNDER CONTAM CLTHG BEFORE REUSE. EYES:FLUSH W/LG AMTS OF
WATER FOR AT LST 15 MINS, LIFTING UPPER & LOWER LIDS OCCAS, GET MED
ATTN. ING EST:DO NOT INDUCE VOMIT. KEEP PERSON WARM & GET MED ATTN.
INHAL:REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN OXYGEN. IF
BRTHG HAS STOPPED, APPLY ARTF RESP. KEEP PERSON WARM, QUIET & GET
MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:102F,39C
Lower Limits:1.1%
Upper Limits:6%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:COMBUST LIQ. VAPS ARE HVR/AIR & MAY
TRAVEL ALONG GROUND/BE MOVED BY VENT & IGNITED BY HEAT, PILOT
LIGHTS, OTHER FLAMES & IGNIT SOURCES AT LOCATIONS DIST(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR
ABSORBANT OR OTHER ABSORBANT MATERIAL & PICK UP W/SHOVEL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED OR REPEATED SKIN
CONTACT. KEEP AWAY FROM HEAT, SPARKS, OPEN FLAMES. USE W/ADEQUATE
VENTILATION.
Other Precautions:COMBUSTIBLE LIQUID UN 1263. NO SPECIAL MARKINGS
REQUIRED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SELF-CONTAINED RESPIRATOR IF
TLV IS REACHED.
Ventilation:LOCAL EXHAUST AS NEEDED TO REMAIN BELOW PEL.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV:1.2-1.35 (H*2O=1). EXPLO HAZ:FROM MATERIAL HANDLING POINT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:320F,160C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:70 (ETHER=1)
Solubility in Water:NONE
Appearance and Odor:WHITE OR COLORED OPAQUE LIQUID; ODOR CHARACTERISTIC
OF MINERAL SPIRITS.
Percent Volatiles by Volume:49-53
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE &/OR CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS. DISPOSE OF
I/A/W LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RIBONUCLEIC ACID
CAGE:GO448
CAGE:GO448
============= Composition/Information on Ingredients =============
Ingred Name:RIBONUCLEIC ACID*97-4*
CAS:63231-63-0
RTECS #:RF0772520
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN, EYE/RESPIRATORY TRACT
IRRITATION UPON CONTACT. ALLERGIC REACTIONS IN CERTAIN SENSITIVE
INDIVIDUALS MAY DEVELOP.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, ALLERGIC REACTIONS.
Medical Cond Aggravated by Exposure:ALLERGIES, ASTHMA.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES/SKIN: WASH THOROUGHLY
W/WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID PHYSICAL CONTACT & DUST DURING REMOVAL.
USE NORMAL CLEAN-UP PROCEDURES & WASH THOROUGHLY W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR DUST MASK.
Ventilation:LOCAL EXHAUST: AS REQUIRED. MECHANICAL (GENERAL): VENT FAN.
Supplemental Safety and Health
SOLUBILITY IN WATER: POWDERS-APPRECIABLE. LIQUIDS-MISCIBLE.
================== Physical/Chemical Properties ==================
Solubility in Water:(SEE SUPP)
Appearance and Odor:POWDERS-WHITE TO TAN/WHITE TO BROWN LIQUIDS
W/TYPICAL ENZYME ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH IN SEWERAGE SYSTEM W/WATER IAW/FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:523 RAM POLYESTER COLORS
CAGE:29431
CAGE:29431
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOHEXANONE (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 8-9%
Other REC Limits:100PPM (SKIN) STEL
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BUTYRIC ACID LACTONE, TETRAHYDRO-2-FURANONE, BLO
CAS:96-48-0
RTECS #:LU3500000
Fraction by Wt: 3-6%
ACGIH TLV:10 PPM
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0.5-2.8%
Other REC Limits:100 PPM
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION & DAMAGE. SKIN:
IRRITATION, RED, & DRY. INHALATION: RESPIRATORY TRACT IRRITATION,
HEADACHE, DIZZINESS, NAUSEA, VOMITING, LOSS OF CONSCIOUSNESS,
KIDNEY, LIVER, & CENTRAL NERVOUS SYSTEM DAMAGE. INGESTION:
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE: IRRITATION & DAMAGE. SKIN: IRRITATION,
RED, & DRY. INHALATION: RESPIRATORY TRACT IRRITATION, HEADACHE,
DIZZINESS, NAUSEA, VOMITING, LOSS OF CONSCIOUSNESS, KIDNEY, LIVER,
& CENTRAL NERVOUS SYSTEM DAMAGE. INGESTION: IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
GIVE CPR IF NEEDED. INGESTION: INDUCE VOMITING. OBTAIN MEDICAL
ATTENTION IN A LL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:111F
Lower Limits:1%
Upper Limits:6.9%
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CO2, & DRY CHEMICAL.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS. USE
WATER FOG TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:VAPOR IS >AIR, IT MAY TRAVEL & IGNITE OR
FLASHBACK. EMPTY CONTAINERS STILL COULD IGNITE EXPLOSIVELY. KEEP
AREA CLEAR OF SOURCES OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/SAND. REMOVE ALL SOURCES OF IGNITION.
DIKE AREA W/SAND TO CONTAIN SPILLED LIQUID. OPEN ALL WINDOWS &
DOORS. PUMP INTO SALVAGE TANK.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS COOL, DRY & AWAY FROM
IGNITION SOURCES. CHECK ALL CONTAINERS FOR LEAKS.
Other Precautions:OVERHEATING MAY CAUSE CONTAINER TO RUPTURE & EMPTY
CONTAINERS CONTAINING RESIDUE MAY CAUSE A HAZARD. AVOID BREATHING
FUMES & CONTACT W/SKIN. DON'T TAKE INTERNALLY. WASH THOROUGHLY
AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A MSHA/NIOSH APPROVED VAPOR RESPIRATOR.
Ventilation:PROVIDE LOCAL EXHAUST/MECHANICAL VENTILATION TO KEEP <TLV.
IMPERVIOUS CLOTHING & BOOTS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PRODUCT DOES NOT CONTAIN LEAD OR CHROMATE PIGMENTS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:279-313F
Vapor Pres:1.22-2.0
Vapor Density:3.38-3.42
Spec Gravity:0.969-1.464
Evaporation Rate & Reference:SLOWER THAN BU AC
Solubility in Water:<0.1%
Appearance and Odor:CLEAR & COLORED PASTE W/PUNGENT ODOR.
Percent Volatiles by Volume:66-71%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALKALIES, & ACIDS.
Stability Condition to Avoid:EXTREME HEAT, COLD, & ELEVATED TEMPS.
Hazardous Decomposition Products:ACRID SMOKE, CO, CO2, & VARIOUS
HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. KEEP MATERIAL OUT OF SEWERS & STREAMS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:B1010-43W 40% POTASSIUM HYDROXIDE
CAGE:0GWU4
CAGE:0GWU4
============= Composition/Information on Ingredients =============
Ingred Name:WATER, H2O
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70%
Ingred Name:POTASSIUM HYDROXIDE
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 10%
Other REC Limits:2 MG/CUM (CEILING)
OSHA PEL:2 MG/CUM (CEILING)
ACGIH TLV:2 MG/CUM (CEILING)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:GLYCERINE, 1,2,3,-TRIHYDROXYPROPANE, GLYCEROL, ANHYDROUS
GLYCERINE, GLYCERIN
CAS:56-81-5
RTECS #:MA8050000
Fraction by Wt: 20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 (MIST) 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL (RAT) LD50: 12,600 MG/CUM
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INHALATION:
GASTROINTESTINAL TRACT & LUNG IRRITATION. INGESTION: FATAL,
BLINDNESS & BURNS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN: IRRITATION. INHALATION:
GASTROINTESTINAL TRACT & LUNG IRRITATION. INGESTION: FATAL,
BLINDNESS & BURNS.
Medical Cond Aggravated by Exposure:RESPIRATORY ILLNESS
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS.
INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK LARGE AMOUNTS OF
WATER OR MILK. DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL, ALCOHOL FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. USE
WATER TO COOL FIRE EXPOSED CONTAINERS & TO REDUCE FLAME INTENSITY.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR FULL PROTECTIVE CLOTHING. NEUTRALIZE &
FLUSH TO SEWER.
======================Handling and Storage ======================
Handling and Storage Precautions:ATTACKS GLASS CONTAINERS SLOWLY. STORE
ACCORDINGLY. DON'T EAT, DRINK OR SMOKE WHILE HANDLING PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AN APPROVED RESPIRATOR EQUIPPED W/HIGH
EFFICIENCY PARTICULATE & MIST FILTER.
Ventilation:LOCAL EXHAUST/MECHANICAL & GENERAL
Other Protective Equipment:APPROVED WORK CLOTHES, EYEWASH, QUICK DRENCH
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING & SHOES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:15
Vapor Density:3.17
Spec Gravity:1.15
Evaporation Rate & Reference:(BU AC = 1): <1
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, SLIGHTLY VISCOUS LIQUID W/SLIGHT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, FLAMMABLE LIQUIDS, ALUMINUM NITRO METHANE, ZINC,
HYDROGENATED HYDROCARBONS
Stability Condition to Avoid:MOISTURE
Hazardous Decomposition Products:HYDROGEN GAS, FLAMMABLE/CORROSIVE GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RECHARGEABLE BATTERIES
CAGE:56309
Contract Num:SP0400-99-A-AF31
CAGE:1CW50
CAGE:56309
CAGE:89178
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM & CADMIUM HYDROXIDE
Minumum % Wt:13.
Maxumum % Wt:16.
Other REC Limits:0.05 MG/M3
Ingred Name:NICKEL & NICKEL HYDROXIDE
Minumum % Wt:20.
Maxumum % Wt:30.
Other REC Limits:1.0 MG/M3
Ingred Name:POTASSIUM HYDROXIDE OR SODIUM HYDROXIDE
Minumum % Wt:2.
Maxumum % Wt:4.
Other REC Limits:2.0 MG/M3
Ingred Name:COBALT HYDROXIDE
CAS:21041-93-0
RTECS #:GG0904500
Minumum % Wt:.5
Maxumum % Wt:1.
Other REC Limits:0.1 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EACH BATTERY CELL IS A SEALED
CYLINDRICAL CONTAINER. IF BROKEN, LEAKING OR IN FIRE: ACUTE -
POTASSIUM HYDROXIDE, SODIUM HYDROXIDE: BURNS TO TISSUE CONTACTED;
NICKEL: POSSIBLE CONTACT DERMATITIS. INGES TION CAUSES STOMACH
IRRITATION. CHRONIC- CADMIUM: POSSIBLE LUNG OR KIDNEY DAMAGE;
NICKEL: POSSIBLE LUNG DAMAGE.
Explanation of Carcinogenicity:CONTAINS CADMIUM AND NICKEL.
Effects of Overexposure:IF IN FIRE OR LEAKING: BURNS, IRRITATION, PAIN
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED: REMOVE TO
FRESH AIR. CALL PHYSICIAN. EYES: FLUSH WITH WATER FOR 15 MINUTES.
HOLD EYELIDS OPEN. SEE PHYSICIAN. SKIN: WASH WITH LARGE AMOUNT OF
WATER; MILD ACID MAY BE USED TO NEUTRALIZE THE BASE. SWALLOWED: IF
BATTERY/OPEN BATTERY IS INGESTED, DO NOT INDUCE VOMITING OR GIVE
FOOD/DRINK. SEEK IMMEDIATE MEDICAL ATTENTION. CALL NATIONAL BATTERY
INGESTION H OTLINE FOR ADVICE & FOLLOWUP (202-625-3333).
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:IF INCINERATED NIOSH/MSHA APPROVED POSITIVE
PRESSURE SCBA.
Unusual Fire/Explosion Hazard:TOXIC CADMIUM OXIDE FUMES MAY BE RELEASED
DURING BURNING.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH ELECTROLYTE SPILLS WITH WATER. DO NOT
BREAK OPEN BATTERY CELL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. DO NOT
SHORT CIRCUIT, MAY CAUSE BURNS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DO NOT BREAK OPEN
BATTERY CELL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SCBA (IF BURNED)
Ventilation:ADEQUATE
Other Protective Equipment:EYE BATH, WASHING FACILITY, LAB COAT OR
UNIFORM.
Work Hygienic Practices:GOOD PRACTICE REQUIRES THAT GROSS AMOUNT OF ANY
CHEMICAL BE REMOVED FROM THE SKIN AS SOON AS PRACTICAL.
Supplemental Safety and Health
PART NUMBER: 13-175; A19460-1. DO NOT BREAK OPEN BATTERY CELL. PROTECT
AGAINST CRACKING OF CASE MATERIAL. ADHERE TO PROPER CHARGING
PROCEDURE.
================== Physical/Chemical Properties ==================
HCC:Z5
Appearance and Odor:EACH BATTERY CELL IS A SEALED CYLINDRICAL CONTAINER
ENCLOSING ELECTROLYTES.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT, FIRE
Hazardous Decomposition Products:TOXIC FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL LAWS AND REGULATIONS. DO NOT INCINERATE OR
MUTILATE BATTERIES.
=================== MSDS Transport Information ===================
Transport Information:THESE BATTERIES ARE CONSIDERED "MANUFACTURED
ARTICLES" AS DEFINED IN 49 CFR 1910-1200 (C).
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CALIBRATION GAS CO45-55 PPM IN AIR, 51-2277
CAGE:05083
CAGE:05083
============= Composition/Information on Ingredients =============
Ingred Name:CARBON MONOXIDE
CAS:630-08-0
RTECS #:FG3500000
Fraction by Wt: 0.005%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM; 9293
Ingred Name:AIR, COMPRESSED
Fraction by Wt: 99.995%
Ingred Name:SUPP DATA:SINCE THIS GAS IS ODORLESS, AREAS OF USE OR WHERE
CO IS VENTED & CO MAY COLLECT SHOULD BE MONITORED (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: TO ASSURE THAT THE CONCENTRATIONS ARE MAINTAINED
BELOW THE PEL.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LC50(RAT): 1807 PPM/4HR
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:(ACUTE) EYES & SKIN: NONE KNOWN OR
EXPECTED. INHAL: CO IS A CHEM ASPHYXIANT WHICH AFFECTS OXYGEN
TRANSPORT OF THE BLOOD. SYMP INCL HDCH, POUNDING HEART, DIZZ,
WEAKNESS, CONFUSN & NAUS. DEATH MAY RESUL T FROM INTENSE/PRLNGD
EXPOS. INGEST: NOT APPLIC. THIS MATL IS A GAS. (CHRONIC) EXPOS TO
LOW LEVS OF(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CO MAY ADVERSELY AFFECT CARDIOVASCULAR
SYSTEM. IRRITANCY: MATL IS NOT IRRIT TO TISS. SENSIT: NOT A
SENSITIZER. REPRO TOX: CO HAS BEEN RPTD TO CAUSE ADVERSE EFTS ON
FERTILITY IN SOME ANIMAL ST UDIES. TERATOGENICITY: CO HAS BEEN
RPTDTO CAUSE DEVELOPMENTAL ABNORMALITIES & FETAL TOX IN ANIMAL
STUDIES. (SUPP DATA)
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING
RESPIRATORY DISEASE AND SMOKERS MAY BE AT INCREASED RISK FROM
EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYE & SKIN: NONE NEEDED. INHAL: RESCUERS SHOULD BE AWARE OF
HAZARD AND WEAR SCBA. REMOVE VICTIM FROM AREA TO FRESH AIR, GIVE
ARTIFICIAL RESPIRATION, GET MD IMMEDIATELY. INGEST: NONE NEEDED.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Lower Limits:12.5%
Upper Limits:74% (CO)
Extinguishing Media:THIS GAS IS NOT FLAMMABLE. COOL EXPOSED CNTNRS WITH
WATER. USE MEDIA SUITABLE FOR SURROUDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROT EQUIP
. USE SHIELDING TO PROTECT FROM CYLINDER EXPLOSION.
Unusual Fire/Explosion Hazard:CONC OF CO IS 125F MAY CAUSE RUPTURE. SECURE CYL-DO NOT DROP.
OUTDOOR STORAGE PREFERRED.
Other Precautions:DO NOT BREATHE GAS. CONTENTS UNDER PRESS. DO NOT
PUNCTURE. NEVER THROW CNTNR IN FIRE/INCINERATOR. KEEP CYL SECURED.
DO NOT DROP/DMG. USE PRESS REGULATOR & CHECK VALVES AS APPROP. KEEP
CYL AWAY FROM HE AT, FLAMES & ALL IGNIT (SEE SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVED POSITIVE PRESS SCBA FOR EMER
USE. DO NOT BREATHE GAS. SELECTION OF RESP PROT DEPENDS ON
CONTAMINANT TYPE, FORM & CONC. SELECT IN ACCORDANCE WITH OSHA
1910.134 AND GOOD INDUSTRIAL HY GIENE PRACTICE.
Ventilation:LOCAL EXHAUST OR ADEQUATE GENERAL VENTILATION TO MAINTAIN
CONCENTRATION BELOW THE PEL.
Other Protective Equipment:SEE OTHER PRECAUTIONS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:MUTAGENICITY:CO IS MUTAGENIC IN SOME TEST SYSTEMS.
SYNERGISTIC EFTS:METHYLENE CHLORIDE IS METABOLIZED TO CO IN THE
BODY & INCREASES TOXIC EFT OF CO EXPOS. OTHER PREC: SOURCES. FOR
ADDT NL HNDLG REC ON COMPRESSED GAS CYL, CONSULT COMPRESSED GAS
ASSOC PAMPHLET P-1. PROT FROM HEAT & PHYS DMG. (SEE ING 3)
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-317F,-194C
Vapor Density:1
Spec Gravity:0.8
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS, ODORLESS, TASTELESS COMPRESSED GAS IN
CYLINDERS.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:AVOID HEAT OR FLAMES.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT INCINERATE CYLINDER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-L-25567C TYPE I;LEAK DETECTION COMPOUND
CAGE:82925
CAGE:82925
============= Composition/Information on Ingredients =============
Ingred Name:LEAK DETECTION COMPOUNDS (TYPE NOT SPECIFIED)-MFR STATES
NOT HAZARDOUS
ACGIH TLV:NOT SPECIFIED
===================== Hazards Identification =====================
Effects of Overexposure:NONE NOTED BY THE MFR.MAY IRRITATE EYES AND
SKIN.USE PERSONAL CARE.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
NEED;EYES/SKIN:FLUSH W LG AMTS H*2O FOR 15 MIN;INGEST:RINSE MOUTH;
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WILL NOT BURN;USE ANY MEDIA FOR SURROUNDING FIRES.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA IN AN ENCLOSED
AREA.
Unusual Fire/Explosion Hazard:NONE NOTED BY THE MFR.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;DILUTE WITH
WATER,RECOVER FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL REQUIREMENTS:USE NORMAL
CARE DURING HANDLING/STORAGE.
Other Precautions:AVOID CONTACT WITH SKIN AND EYES.WASH AFTER EACH USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQMNTS UNDER ORDINARY
CONDITIONS/ADEQUATE VENT.
Ventilation:NO SPECIAL REQUIREMENTS W ADEQUATE VENT.
Other Protective Equipment:AS REQUIRED TO PREVENT PROLONGED CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:UNDATED
Boiling Pt:B.P. Text:212F/100C
Spec Gravity:0.99
Evaporation Rate & Reference:1.0 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE NOTED
Stability Condition to Avoid:NONE NOTED
Hazardous Decomposition Products:NONE NOTED
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:600 INDUSTRIAL ENAMEL 13655, B60013655
Preparer's Name:PATRICIA SHAW
CAGE:3Z268
CAGE:3Z268
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCARBON MIXTURE (VAPOR PRESSURE 2.0 MM HG @ 68F)
CAS:64741-41-9
Fraction by Wt: 30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: NASAL & RESP IRRIT, NARCOSIS
(CNTRL NERV SYS DEPRESS). EYE: SEVERE IRRIT. SKIN: IRRIT, DEFAT,
DERMATITIS. INGEST: DIGEST TRACT IRRIT, CNTRL NERV SYS DEPRESS.
ASPIRATION HZD. MAT'L ENTER LUNGS ( SWALLOW/VOMIT), LUNG INFLAMM.
CHRONIC: CNTRL NERV SYS/RESP SYS, LUNG, EYE, SKIN, GI TRACT, LIVER,
SPLEEN, KIDNEY DAMAGE.
Effects of Overexposure:INHALATION: DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, AND HEADACHE. EYE: TEARING, REDNESS, AND BLURRED VISION.
Medical Cond Aggravated by Exposure:RESPIRATORY TRACT IRRITATION,
DERMATITIS, NAUSEA.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER 15 MIN, OCCASIONALLY LIFTING EYELIDS. GET
MED ATTN. SKIN: REMOVE CONTAMINATED CLOTHING, WASH W/SOAP & WATER.
IF IRRITATION PERSISTS, SEE DR. INHAL: REMOVE TO FRESH AIR. APPLY
ARTIF RESPIRATION/ADMINISTER OXYGEN IF NEEDED. CONSULT DR. INGEST:
UNLESS DIRECTED BY MED PERSONNEL. IF ADVICE UNAVAIL, TAKE TO EMERG
ROOM.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:104F,40C
Lower Limits:1.0
Upper Limits:6.1
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE EXTINGUISHER (NFPA FLAMMABLE LIQ FIRE).
WATER MAY BE INEFFECTIVE, USE AS FOG FOR COOLING. WEAR FULL
PROTECTIVE CLOTHING & BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPORS FORM EXPLOSIVE MIX W/AIR (LEL TO
UEL) WHICH CAN BE IGNITED BY MANY SOURCES. CLOSED CNTNRS MAY
EXPLODE W/HEAT. ISOLATE FROM HEAT/IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL IGNITION SOURCES. VENTILATE AREA. PROVIDE PROTECTIVE EQUIPMENT.
DIKE AROUND SPILL AREA. COVER SPILL WITH INERT ABSORBENT AND
TRANSFER USING NON-SPARKIN G TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 80 F IN CLOSED CONTAINER.
STORE IN ORIGINAL CONTAINER. AVOID FLAME AND HIGH TEMPERATURES. DO
NOT STORE NEAR OXIDIZING AGENTS OR ACIDS.
Other Precautions:VAPOR IS HEAVIER THAN AIR, MAY TRAVEL CONSIDERABLE
DISTANCE TO IGNITION SOURCE & FLASHBACK. DON'T INGEST OR INHALE.
GROUND ALL CONNECTIONS, CONTAINERS, ETC WHEN POURING OR TRANSFERING
TO MINIMIZE STAT IC ELECTRICITY. USE NON-SPARK TOOLS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA EQUIPMENT WHEN AIRBORNE EXPOSURE
LIMITS ARE EXCEEDED. CONSULT RESPIRATOR MANUFACTURER TO DETERMINE
EQUIPMENT FOR GIVEN APPLICATION. HIGH AIRBORN CONCENTRATIONS MAY
REQUIRE USE OF SUPPLI ED-AIR RESPIRATOR OR SCBA.
Ventilation:PROVIDE VENTILATION TO CONTROL EXPOSURE LEVELS BELOW
AIRBORNE EXPOSURE LIMITS. VENT EQUIPMENT MUST BE EXPLOSION PROOF.
Other Protective Equipment:WEAR IMPERMEABLE APRONS & PROTECT CLOTHES
WHEN POSSIBLE TO PREVENT EXPOSURE OF SKIN. WEAR HEAD CAPS WHEN
POSSIBLE.
Work Hygienic Practices:AFTER USING, WASH BEFORE EATING, TOILETING OR
SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:315F,157C
Vapor Density:> AIR
Spec Gravity:1.1 (WATER=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT WATER SOLUBLE
Appearance and Odor:PIGMENTED LIQUID. SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT EXPOSE TO HEAT OR IGNITION SOURCES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE AND/OR MONOXIDE, LOW MOLECULAR WEIGHT HYDROCARBONS &
ORGANIC ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP OUT OF DRAINS, SEWERS AND WATERWAYS.
DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INK JET INK, RF90-93
CAGE:79981
CAGE:79981
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >70%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALIPHATIC ALCOHOL
Fraction by Wt: <5%
OSHA PEL:400 PPM (MFR)
ACGIH TLV:400 PPM (MFR)
Ingred Name:DYESTUFF
Fraction by Wt: <10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHANOL, 2,2'-THIODI-; (2,2'-THIODIETHANOL)
CAS:111-48-8
RTECS #:KM2975000
Fraction by Wt: <10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:GLYCEROL; (GLYCERIN)
CAS:56-81-5
RTECS #:MA8050000
Fraction by Wt: <10%
OSHA PEL:15 MG/M3 (MIST)
ACGIH TLV:10 MG/M3 (MIST)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: NIL TO MILD SKIN IRRITATION.
CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: WASH IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. GET MEDICAL ATTENTION IMMEDIATELY. INHALATION:
REMOVE FROM EXPOSURE AREA TO FRESH AIR. GET MEDICAL ATTENTION.
INGESTION: ING ESTION OF INK MAY RESULT IN GASTRIC DISTURBANCES.
DILUTE WITH WATER AND GET MEDICAL ATTENTION. SKIN: FLUSH WITH
COPIOUS AMOUNTS OF WATER. SEE MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE DRY CHEMICAL, CARBON DIOXIDE, WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE REQUIRED UNDER USE AS STATED HEREIN.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:GOOD INDUSTRIAL HYGIENE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.03 (H*2O=1)
Solubility in Water:MISCIBLE
Appearance and Odor:PLASTIC CARTRIDGE CONTAINING AQUEOUS LIQ COMPRISED
OF WATER, DYESTUFF, ADDITIVE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE AT NORMAL STORAGE CONDITIONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN COMPLIANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:MOLDE RELEASE 225 AEROSOL
Preparer's Name:LEN PULLMAN
CAGE:22401
CAGE:0RCD8
CAGE:0MTA9
CAGE:22401
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9596
Ingred Name:METHYLENE CHLORIDE (SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 77.28%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOBUTANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR METHYLENE CHLORIDE IS 50 PPM.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYE:MAY CAUSE SEVERE IRRITATION
& BURN.SKIN:MAY CAUSE IRRITATION.INHALE:MAY CAUSE RESPIRATORY
IRRITATION. REPEATED & EXCESSIVE EXPOSURE TO VAPORS MAY CAUSE
KIDNEY,LIVER/LUNG DAMAGE. IN POORLY VE NTILATED AREAS,HIGH
CONCENTRATIONS MAY CAUSE NARCOSIS/EVEN
UNCONSCIOUSNESS/DEATH.ORAL:UNLIKELY.CHRONIC-KIDNEY,LIVER DAMA
Explanation of Carcinogenicity:CONTAINS METHYLENE CHLORIDE KNOWN TO THE
STATE OF CALIFORNIA TO CAUSE CANCER.
Effects of Overexposure:MAY CAUSE SEVERE EYE IRRITATION & BURN. MAY
CAUSE SKIN IRRITATION. INHALATION MAY CAUSE RESPIRATORY IRRITATION.
REPEATED & EXCESSIVE EXPOSURE TO VAPORS MAY CAUSE KIDNEY,
LIVER/LUNG DAMAGE. IN POORLY V ENTILATED AREAS, HIGH CONCENTRATIONS
MAYCAUSE NARCOSIS/ EVEN UNCONSCIOUSNESS/DEATH.
Medical Cond Aggravated by Exposure:CARDIOVASCULAR DISEASE
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN:WASH WITH
SOAP & WATER. EYE:FLUSH WITH WATER FOR 15 MINUTES, HOLDING EYELIDS
OPEN. INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF NEEDED.
ORAL:DO N OT INDUCE VOMITING. GET IMMEDIATE MEDICAL ATTENTION.
VOMITING MAY LEAD TO CHEMICAL PNEUMONITIS, WHICH CAN BE FATAL.
===================== Fire Fighting Measures =====================
Flash Point:AEROSOL,NON-FLAM
Extinguishing Media:WATER SPRAY, CO2, FOAM/DRY CHEMICAL. WATER SPRAY
MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL & FLUSH SPILLS
AWAY.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND NIOSH-
APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL FACEPIECE
OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:THIS PRODUCT CONTAINS EXTREMELY FLAMMABLE
SOLVENTS WHOSE VAPORS MAY FORM EXPLOSIVE MIXTURES WITH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. PREVENT FLOW INTO SEWERS AND
WATERWAYS. CLEAN UP WITH AN INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE- KEEP CONTAINERS COOL, DRY AND
AWAY FROM SOURCES OF IGNITION. USE AND STORE THIS PRODUCT WITH
ADEQUATE VENTILATION.
Other Precautions:AVOID BREATHING VAPORS OR MISTS. DO NOT GET IN EYES,
ON SKIN OR ON CLOTHING. WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR DRINKING. REMOVE CONTAMINATED CLOTHING PROMPTLY. KEEP OUT
OF REACH OF C HILDREN. FOR INDUSTRIAL USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NON REQUIRED UNDER NORMAL CONDITIONS. IF HIGH
VAPOR OR MIST CONCENTRATIONS EXPECTED, USE NIOSH-APPROVED
RESPIRATOR FOR ORGANIC VAPORS AND MISTS. WEAR SUPPLIED-AIR
RESPIRATOR PROTECTION IN CONFINED OR ENCLOSED SPACES, IF NEEDED.
Ventilation:NORMAL VENTILATION IS ADEQUATE.LOCAL EXHAUST SHOULD BE USED
WHEN LARGE AMOUNT IS RELEASED.USE MECHANICAL FOR LOW PLACES.
Other Protective Equipment:EYE WASH STATION, QUICK DRENCH SHOWER AND
IMPERVIOUS CLOTHING
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATIONS, SEE PNI A OR B UNDER THE
SAME NSN.
================== Physical/Chemical Properties ==================
HCC:V2
Boiling Pt:=39.4C, 103.F
Vapor Pres:340 @ 68F
Vapor Density:>1
Spec Gravity:1.008
Evaporation Rate & Reference:<1 (ETHER = 1)
Appearance and Odor:LIQUID
Percent Volatiles by Volume:91
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AMINES, ALUMINUM AND MAGNESIUM
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES, SPARKS, HOT
SURFACES AND OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE, CARBON
DIOXIDE, OXIDES OF NITROGEN AND HYDROGEN CHLORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT PUNCTURE OR INCINERATE AEROSOL CANS.
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PVC CEMENT
CAGE:HO558
CAGE:HO558
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOHEXANONE (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 2%
Other REC Limits:N/K
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TETRAHYDROFURAN (SARA III)
CAS:109-99-9
RTECS #:LU5950000
Fraction by Wt: 37%
Other REC Limits:N/K
OSHA PEL:200 PPM/250 STEL
ACGIH TLV:200 PPM/250STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 47%
Other REC Limits:N/K
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PVC RESIN (POLYVINYL CHLORIDE)
CAS:9002-86-2
RTECS #:KV0350000
Fraction by Wt: 14%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LIQUID HAS NORMAL DEFATTING EFFECT OF
SOLVENTS ON TISSUE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:IRRITATION.SKIN:LIQUID HAS NORMAL
DEFATTING EFFECT OF SOLVENTS ON TISSUES.INGESTION:N/K
.INHALATION:SEVERE OVEREXPOSURE TO VAPOR MAY PRODUCE NARCOSIS.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES.SKIN:N/K .INGESTION:DO NOT INDUCE VOMITING.CALL
MD.INHALATION:REMOVE TO FRESH AIR.SUPPORT BREATHING (GIVE
O*2/ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:6F,-14.44C
Lower Limits:11.8
Upper Limits:2
Extinguishing Media:ANSUL "PURPLE-K POTASSIUM BICARBONATE","AERO-FOAM"
ALCOHOL RESISTANT FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PEROXIDES MAY FORM ON LONG STANDING WHICH
SHOULD BE DESTROYED BEFORE DISTILLATION.HIGH CONC OF PEROXIDES CAN
REACT WITH ALKALIS.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID PROLONGED BREATHING OF VAPOR AND CONTACT
WITH EYES AND SKIN.SHUT OFF SOURCE.IF POSSIBLE DAM.ELIMINATE SPARKS
AND ALL OTHER SOURCES OF IGNITION AND ALLOW TO EVAPORATE.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT,SPARKS AND OPEN
FLAME.KEEP CONTAINER TIGHTLY CLOSED.STORE IN COOL LOCATION.
Other Precautions:WASH THOROUGHLY AFTER USING.DO NOT DISTILL TO DRYNESS
UNLESS ABSENCE OF PEROXIDES HAS BEEN VERIFIED BY TEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:N/K
Work Hygienic Practices:WASH THOROUGHLY AFTER USING.
Supplemental Safety and Health
N/K
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:151F,66.11C
Decomp Temp:Decomp Text:N/K
Vapor Pres:143 MMHG
Vapor Density:2.49,AIR=1
Evaporation Rate & Reference:N/K
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,ETHEREAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
N/K
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:N/K
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NC BRAKE CLEANER II, 7815489
Resp. Party Other MSDS Num.:301.0347302-001.001
CAGE:44633
CAGE:44633
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
Minumum % Wt:49.
Maxumum % Wt:53.
OSHA PEL:2400 MG/M3;1000 PPM
ACGIH TLV:1780 MG/M3;750 PPM
ACGIH STEL:2380 MG/M3;1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:HEXANE
CAS:110-54-3
RTECS #:MN9275000
= Wt:27.
OSHA PEL:1800 MG/M3;500 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ISOPROPANOL
CAS:67-63-0
RTECS #:NT8050000
Minumum % Wt:11.
Maxumum % Wt:15.
OSHA PEL:980 MG/M3;400 PPM
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
Ingred Name:LIGHT ALIPHATIC SOLVENT NAPHTHA (PETROLEUM); (ALIPHATIC
PETROLEUM DISTILLATES)
CAS:64742-89-8
Minumum % Wt:8.
Maxumum % Wt:12.
Ingred Name:ACETALDEHYDE
CAS:75-07-0
RTECS #:AB1925000
OSHA PEL:360 MG/M3;200 PPM
ACGIH STEL:C45 MG/M3;C25 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:FORMALDEHYDE
CAS:50-00-0
RTECS #:LP8925000
OSHA PEL:see 1910.1048
ACGIH STEL:C0.37 MG/M3;C0.3 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:BENZENE
CAS:71-43-2
RTECS #:CY1400000
OSHA PEL:see 1910.1028
ACGIH TLV:32 MG/M3;10 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
OSHA PEL:see Table Z-2
ACGIH TLV:188 MG/M3;50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:BENZENE & TOLUENE APPEAR ON THE NAVY
LIST OF OCCUP CHEM REPRO HAZS. SEEK CONSULTATION FROM APPROP HEALTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS
INFO . EYE: CAN CAUSE IRRIT. SYMPS INCL STINGING, TEARING, REDNESS
& SWELL. SKIN:MAY CAUSE MILD IRRIT. PRLNGD/RPTD CNTCT MAY DRY SKIN.
SYMPS MAY INCL REDNESS, BURNING, DRYING & CRACKING OF SKIN & SKIN
BURNS. PASSAGE OF MAT L INTO BODY THRU SKIN IS POSS, BUT IS
UNLIKELY THIS WOULD RSLT IN HARMFUL EFTS DURING SAFE HNDLG & USE.
INGEST:SWALLOWING SM AMTS DURING NORM HNDLG IS NOT LIKELY TO CAUSE
HARMFUL EFTS; LG AMTS MAY BE HARMFUL. MATL CAN GET (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:FORMALDEHYDE:IARC MONO, SUPP, VOL 62, PG
217, 1995:GROUP 2A. NTP 8TH ANNUAL RPT ON CARCINS, 1998:ANTIC TO BE
CARCIN. OSHA REGULATED:CFR 29 1910.1048. BENZENE: IARC MONO, SUPP,
VOL 7, PG 120, 1987:GRP 1. NTP 8TH ANNUAL RPT ON CARCINS,
1998:KNOWN TO BE CARCIN. OSHA REGULATED:CFR 29 1910.1028.
Effects of Overexposure:HLTH HAZS: INTO LUNGS DURING SWALLOW/VOMIT
W/LUNG INFLAM & OTHER LUNG INJURY. INHAL:BRTHG VAP/MIST IS POSS.
BRTHG SM AMTS DURING NORM HNDLG NOT LIKELY TO CAUSE HARMFUL EFTS;
LG AMTS MAY BE HARMFUL. SY MPS USUALLY OCCUR AT AIR CONCS HIGHER
THAN RECOM EXPOS LIMS. SIGNS OF EXPOS TO MATL THRU INHAL, INGEST
&/OR PASSAGE OF MATL THRU SKIN MAY INCL; MOUTH & THROAT IRRIT
(SORENESS, DRY/SCRATCHY FEELING, CO UGH), STOM/INTESTINAL UPSET
(NAUS, VOMIT, DIARR), IRRIT (NOSE, THROAT, AIRWAYS), COUGH, CNS
DEPRESS (DIZZ, DROW, WEAK, FATG, NAUS, HDCH, UNCON) & OTHER CNS
EFTS, LOW BLOOD PRESS, MILD, TEMPORARY CHGS IN (SUPDAT)
Medical Cond Aggravated by Exposure:PREEXISTING DISORDERS OF FOLLOWING
ORGANS (OR ORGAN SYSTEMS)MAY BE AGGRAVATED: RESPIRATORY TRACT,
SKIN, LUNGS (FOR EXAMPLE ASTHMA-LIKE CNDTNS), LIVER, KDNEY, CNS,
BLOOD-FORM SYS, MALE REPRO SYS.
======================= First Aid Measures =======================
First Aid:EYES:IMMED MOVE FROM EXPOS & INTO FRESH AIR. FLUSH EYES
GENTLY W/WATER FOR AT LST 15 MIN WHILE HOLDING LIDS APART; SEEK
IMMED MED ATTN. SKIN:REMOVE CONTAM CLTHG. WASH AREA W/SOAP & WATER.
IF SYMPS PER SIST, SEEK MED ATTN. LAUNDER CLTHG BEFORE REUSE.
INGEST:SEEK MED ATTN. IF DROWSY/UNCON, DO NOT GIVE ANYTHING BY
MOUTH; PLACE ON LEFT SIDE W/HEAD DOWN. CNTCT MD, MED FACILITY/POIS
CTL CTR FOR ADVICE ON WHETHER TO INDUCE VOMIT. IF POSS, DO NOT
LEAVE UNATTENDED. INHAL:MOVE AWAY FROM EXPOS & INTO FRESH AIR. IF
SYMPS PERSIST, SEEK MED ATTN. IF BRTHG DFCLT, ADMIN OXYG. KEEP WARM
& QUIET; SEEK IMMED MED ATTN. NOTE TO MD: (TOXICOLOGICAL INFO)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<-18.3C, -1.F
Lower Limits:1.0%
Upper Limits:12.8%
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . REFER TO PERSONAL PROTECTIVE EQUIPMENT SECTION OF MSDS.
NFPA RATING: HEALTH -, FLAMMABILITY -3, REACTIVITY - 0.
Unusual Fire/Explosion Hazard:MATL HIGHLY VOLAT; READILY GIVES OFF
VAPS. MAY TRAVEL ALONG GROUND/BE MOVED BY VENT & IGNITED BY PILOT
LIGHT/OTHER FLAME, SPK, HEATER, SMKNG, ELEC MOTOR, STATIC
DISCHARGE/OTHER IGNIT SOURCES AT LOCATI ONS DISTANT FROM MATL HNDLG
PT. NEVER USE WELD/CUT TORCH ON/NEAR DRUM(EVEN EMPTY); PROD (EVEN
RESIDUE) CAN IGNITE EXPLO.
================== Accidental Release Measures ==================
Spill Release Procedures:SM SPILL:ABSORB LIQ ON VERMICULITE, FLOOR
ABSORB/OTHER ABSORB MATL & TRANSFER TO HOOD. LG SPILL:ELIM ALL
IGNIT SOURCES (FLARES, FLAMES INCL PILOT LIGHTS, ELEC SPKS). EXLUDE
FROM AREA PERS NOT WEARINGPROT EQUIP UNTIL CLEAN-UP COMPLETED.
STOP SPILL AT SOURCE. PVNT FROM ENTERING DRAINS, SEWERS,
STREAMS/OTHER BODIES OF WATER. PVNT SPREADING. IF RUNOFF OCCURS,
NOTIFY AUTHS AS REQD. (ECOLOGICAL INFO)
======================Handling and Storage ======================
Handling and Storage Precautions:CNTNRS OF MATL MAY BE HAZ WHEN
EMPTIED. SINCE EMPTIED CNTNRS RETAIN PROD RESIDUES (VAP, LIQ &/OR
SOLID), ALL HAZ PRECS GIVEN MUST BE OBSERVED. ALL 5-GAL PAILS &
LARGER METAL CNTNRS, INCL TANK CARS & T ANK TRUCKS SHOULD BE
GROUNDED & BONDED WHEN MATL TRANSFERRED. HYDROCARB SOLVS
(ECOLOGICAL INFO)
Other Precautions:WARNING:SUDDEN RELS OF HOT ORG CHEM VAPS/MISTS FROM
PROCESS EQUIP OPERATING AT ELEVATED TEMP & PRESS, OR SUDDEN INGRESS
OF AIR INTO VACUUM EQUIP, MAY RSLT IN IGNITS W/OUT PRESENCE OF
OBVIOUS IGNIT SOU RCES. PUBLISHED "AUTOIGNIT" OR "IGNIT" TEMP
VALUES CANNOT BE TREATED AS SAFE (TRANSPORT INFO)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKPLACE EXPOS LIM(S) OF PROD/ANY COMPONENT
IS EXCEEDED, NIOSH APPRVD AIR SUPPLIED RESPIRATOR IS ADVISED IN
ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA REGS ALSO PERMIT
OTHER NIOSH APPRVD RESPIR ATORS (NEG PRESS TYPE) UNDER SPECIFIED
CNDTNS (SEE YOUR INDUSTRIAL HYGIENIST). ENGINEERING OR
ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE EXPOS.
Ventilation:PROVIDE SUFFICIENT MECH (GEN &/OR LOC EXHST) VENT TO
MAINTAIN EXPOS BELOW TLV(S). EXPOS GUIDELINES: ACETONE - OSHA VPEL
750PPM-TWA; OSHA VPEL (TRANSPORT INFO)
SUPPLIER).
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . TO PREVENT REPEATED OR PROLONGED SKIN CONTACT,
WEAR IMPERVIOUS CLOTHING AND BOOTS.
Supplemental Safety and Health
EFTS OF OVEREXP: LIVER, EFTS ON HEART RATE, RESP DEPRESS (SLOWING OF
BRTHG RATE), LOSS OF COORD, CONFUSN, HIGH BLOOD SUGAR, LUNG EDEMA
(FLUID BUILDUP IN LUNG TISS), KIDNEY DMG, COMA. THIS MATL (OR COM
PONENT) SHORTENS TIME OF ONSET OR WORSENS LIVER & KIDNEY DMG
INDUCED BY OTHER CHEMS. PRLNGD & RPTD (OTHER INFO)
================== Physical/Chemical Properties ==================
Boiling Pt:=56.1C, 133.F
B.P. Text:FOR COMPONENT
Vapor Pres:185 MMHG @68F (COMPONENT)
Vapor Density:>1 (AIR=1)
Spec Gravity:0.754 @ 77F
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Appearance and Odor:HOMOGENOUS SOLUTION; LIQUID; ODDOR-NO DATA.
Percent Volatiles by Volume:NO DATA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH: ACETALDEHYDE, ACIDS, CHLORINE, ETHYLENE OXIDE,
ISOCYANATES, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT USE WITH ALUMINUM EQUIPMENT AT
TEMPERATURES ABOVE 120F.
Hazardous Decomposition Products:MAY FORM: CARBON DIOXIDE AND CARBON
MONOXIDE, VARIOUS HYDROCARBONS.
=================== Toxicological Information===================
Toxicological Information:NO DATA. OTHER INFO: ONLY AT EXPOS LEVELS
THAT HARM PREGNANT ANIMAL. RELEVANCE OF FINDINGS TO HUMANS IS
UNCERTAIN. BASED ON AVAIL INFO, MATL CANNOT BE CLASSIFIED W/REGARD
TO CARCIN. FIRST AID PROC: IN HAL OF HIGH CONCS OF MATL, AS COULD
OCCUR IN ENCLSD SPACES/DURING DELIB ABUSE, MAY BE ASSOC W/CARD
ARRHY. SYMPATHOMIMETIC DRUGS MAY INITIATE CARD ARRHYS IN PERS EXPOS
TO MATL. MATL IS ASPIR HAZ. POTNT L DANGER FROM ASPIR MUST BE
WEIGHED AGAINST POSS ORAL TOX WHEN DECIDING WHETHER TO INDUCE
VOMIT. MATL (OR COMPONENT) HAS PRDCED HYPERGLYCEMIA & KETOSIS
FOLLOWING SUBSTANTIAL INGEST. SEE ALSO MED CNDTN S AGGRAVATED.
===================== Ecological Information =====================
Ecological:NO DATA. SPILL PROC: PUMP OR VACUUM TRANSFER SPILLED PROD TO
CLEAN CNTNRS FOR RECOVERY. ABSORB UNRECOVERABLE PROD. TRANSFER
CONTAM ABSORB, SOIL & OTHER MATLS TO CNTNRS FOR DISP. PVNT RUN-OFF
TO SEWERS , STREAMS OR OTHER BODIES OF WATER. IF RUN-OFF OCCURS,
NOTIFY PROPER AUTHS AS REQD, THAT SPILL HAS OCCURRED. HNDLG/STOR
PRECS:BASICALLY NON-CONDUCTORS OF ELEC & CAN BECOME
ELECTROSTATICALLY CHARGED DU RING MIXING, FILTERING OR PUMPING AT
HIGH FLOW RATES. IF THIS CHARGE REACHES A SUFFICIENTLY HIGH LEVEL,
SPARKS CAN FORM THAT MAY IGNITE VAPS OF FLAMMABLE LIQUIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . WASTE MANAGEMENT INFORMATION: NOT
APPLICABLE.
=================== MSDS Transport Information ===================
Transport Information:DOT INFORMATION - 49 CFR 172.101. DOT
DESCRIPTION: PAINT RELATED MATL, 3, UN1263, II. CNTNR/MODE: 55 GAL
DRUM/TRUCK PACKAGE. NOS COMPONENT: NONE. RQ - 49 CFR 172.101: N/A.
OTHER PRECS: OPERATING TEMPS IN CHEM PROCESSES W/OUT ANALYSIS OF
ACTUAL PROCESS CNDTNS. ANY USE OF THIS PROD IN ELEVATED TEMP
PROCESSES SHOULD BE THOROUGHLY EVALUATED TO ESTABLISH & MAINTAIN
SAFE OPERATING CNDTNS. VENT: VPEL 100 0PPM-STEL; ACGIH TLV
750PPM-TWA; ACGIH TLV 1000 PPM-STEL. HEXANE - OSHA VPEL 50PPM-TWA;
ACGIH TLV 50PPM-TWA. ISOPROPANOL - OSHA VPEL 400PPM-TWA; OSHA VPEL
500PPM-STEL; ACGIH TLV 400PPM-TWA; (SARA REG INFO)
===================== Regulatory Information =====================
SARA Title III Information:SARA 303 COMPONENTS - 40 CFR 355 APPENDIX A:
NONE. SECTION 311/312 HAZARD CLASS - 40 CFR 370.2: IMMEDIATE,
DELAYED, FIRE. SARA 313 COMPONENTS - 40 CFR 372.65: SECTION 313
COMPONENT: N-HEXANE 110-45-3 26.50%. TRANSPORT INFO: ACGIH TLV
500PPM-STEL. ALIPHATIC PETROLEUM DISTILLATES OSHA VPEL 300PPM-TWA;
OSHA VPEL 400PPM-STEL; ACGIH TLV 300PPM-TWA. PHYSICAL DATA - LIQUID
DENSITY: 6.270 LBS/GAL @ 77F; 0 .754 KG/L @ 25C.
Federal Regulatory Information:TSCA STATUS: THE INTENTIONAL INGREDS OF
PROD ARE LISTED. CERCLA RQ - 40 CFR 302.4(A): ACETONE RQ 5000 LBS;
HEXANE 5000 LBS. CERCLA RQ - 40 CFR 302.4(B): MATLS W/OUT A
"LISTED" RQ MAY BE REPORTABLE AS 'UNLISTED HAZ SUBSTANCE." SEE 40
CFR 302.5(B). INTERNATIONAL REGS INVENTORY STATUS:NOT DETERMINED.
State Regulatory Information:CA PROPOSITION 65: PROD CNTNS FOLLOWING
SUBSTANCE(S) KNOWN TO STATE OF CA TO CAUSE CANCER: ACETALDEHYDE,
FORMALDEHYDE (GAS), BENZENE. THIS PROD CNTNS FOLLOWING SUBSTANCES
KNOWN TO STATE OF CA TO CAUSE REPRO HARM: BENZENE, TOLUENE. NJ RTK
LABEL INFO: ACETONE 67-64-1, N-HEXANE 110-54-3, ISOPROPYL
ALCOHOL67-63-0, NAPHTHA, SOLVENT 64742-89-8. PA RTK LABEL INFO:
2-PROPANONE 67-64-1, HEXANE 110-54-3, 2- PROPANOL 67-63-0,
ALIPHATIC PETRO DISTILLATES 64742-89-8.
======================= Other Information =======================
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-015-2273
Product ID: 6901211,MAGNETIC PIPE PLUG
Cage: 36540
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 36540
=======================================================
Contractor Summary
=======================================================
Cage: 36540
Cage: 5N366
Cage: 14414
=======================================================
Item Description Information
=======================================================
Item Manager: S9C
Item Name: PLUG,PIPE,MAGNETIC
Specification Number: NONE
Type/Grade/Class: NONE
Unit of Issue: EA
UI Container Qty: 1
Type of Container: PIPE PLUG
=======================================================
Ingredients
=======================================================
% Wt: 100
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: NONE
Explanation Of Carcinogenicity: NONE
Medical Cond Aggravated By Exposure: NONE
First Aid: NONE REQUIRED.
=======================================================
Handling and Disposal
=======================================================
Handling And Storage Precautions: STANDARD STORAGE FOR MAGNETIC MATERIAL.
Other Precautions: NONE
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: NON-FLAMMABLE PIPE PLUG.
Fire Fighting Procedures: USE PROCEDURE APPROPRIATE FOR SURROUNDING FIRE.
Unusual Fire/Explosion Hazard: NONE
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED.
Ventilation: NORMAL.
Other Protective Equipment: NONE REQUIRED
Work Hygienic Practices: NORMAL
Supplemental Safety and Health: MAGNET LIFTING RATING: 10.0 OZ. MANUFACTURER
MARKS ON PACKAGE: DO NOT X-RAY, DO NOT SCAN, MAGNETIC MATERIAL. ITEM IS NOT
REGULATED FOR TRANSPORTATION. NEW/
ADDITION AL PART NUMBER FOR THIS ITEM: 5054051
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
Spec Gravity: METAL
Solubility in Water: NONE
Appearance and Odor: MAGNETIC PIPE PLUG WITH 0.160 IN WIDE X 0.4 IN LONG MAGNET
Percent Volatiles by Volume: 0.0
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE
Hazardous Decomposition Products: NONE
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 43722
Product ID: 6901211,MAGNETIC PIPE PLUG
Review Date: 11/09/1998
Net Unit Weight: UNKNOWN
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: EA
Container QTY: 1
Type Of Container: PIPE PLUG
Additional Data: MAGNET LIFTING WT: 10 OZ. MANUFACTURER MARKS PACKAGE WITH
FOLLOWING INFORMATION: DO NOT X-RAY, DO NO T SCAN, MAGNETIC MATERIAL.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: 6901211,MAGNETIC PIPE PLUG
Cage: 36540
Company Name: LISLE CORP
Street: 807 E MAIN STREET
Zipcode: 51632-2342
Date Of Label Review: 11/09/1998
Status Code: C
Label Date: 11/09/1998
Hazard And Precautions: NONE
=======================================================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:98268 MUELLAR HINTON II BROTH(CA & MG SUPPLY),5 ML
CAGE:05545
CAGE:05545
CAGE:15481
============= Composition/Information on Ingredients =============
Ingred Name:PREPARED TUBED AND MYCOFLASK MEDIA - CLASSIFIED AS GENERAL
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS MATERIAL CONTAINS NO HAZARDOUS
MATERIALS AS DEFINED BY OSHA STANDARD.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATERSPRAY
Fire Fighting Procedures:IF INVOLVED IN A FIRE, EXTINGUISHING MEDIA FOR
SURROUNDING MATERIAL SHOULD BE APPROPRIATE.
Unusual Fire/Explosion Hazard:PRODUCT WILL NOT BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PAPER TOWELS TO PICK UP LIQUID &/GELLED
MATERIAL. WASH AREA W/SOAP & WATER AFTER CLEANUP IS COMPLETED.
======================Handling and Storage ======================
Handling and Storage Precautions:DIRECTIONS FOR USE SHOULD BE READ &
FOLLOWED CAREFULLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Ventilation:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Other Protective Equipment:NOT REQUIRED UNDER NORMAL USAGE.
Work Hygienic Practices:GOOD PERSONAL HYGIENE SHOULD BE PRACTICED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:BROTH: CLEAR TO TRACE OF HAZY LIQUID OF VARING
COLORS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:OBSERVE ASEPTIC TECHNIQUES & PRECAUTIONS AGAINST
MICROBIOLOGICAL HAZARDS. AFTER USE, PREPARED TUBED MEDIA, SPECIMEN
CONTAINERS & OTHER CONTAMINATED MATERIALS MUST BE STERILIZED BY
AUTOCLAVING. DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:TAD 45 RUNWAY DEICER
CAGE:1JZT4
CAGE:1JZT4
Contract Num:SP0450-01-D-4068
CAGE:0VTU2
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM ACETATE
CAS:127-08-2
RTECS #:AJ3325000
= Wt:50.
ACGIH TLV:NONE ESTABLISHED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
= Wt:49.
ACGIH TLV:NONE ESTABLISHED
Ingred Name:CORROSION INHIBITORS
< Wt:1.
ACGIH TLV:NONE ESTABLISHED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL TOXICITY LD50 5000MG/KG (RATS).
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: SLIGHTLY IRRITATING TO EYES &
CAUSE PROLONGED (DAYS) IMPAIRMENT OF VISION. DEGREE OF INJURY WILL
DEPEND ON AMOUNT OF MATERIAL THAT GETS INTO EYE, THE SPEED &
THROUGHNESS OF FIRST AID TREATMENT. S KIN: SUBSTANCE NOT EXPECTED
TO CAUSE PROLONGED OR SIGNIFICANT SKIN IRRITATION. THE SYSTEMIC
TOXICITY OF SUBSTANCE NOT DETERMINED. HOWEVER, IT SHOULD BE
NON-TOXIC TO INTERNAL ORGANS IF ON SKIN. INHALAT ION: MATERIAL DOES
NOT PRESENT INHALATION HAZARD. INGESTION: INGESTION MAY CAUSE
IRRITATION OF DIGESTIVE TRACT.
Explanation of Carcinogenicity:THIS MATERIAL IS TOXICOLOGICALLY
HARMLESS AND IS NOT CONSIDERED A CARCINOGEN.
Effects of Overexposure:EYE: SIGNS AND SYMPTOMS MAY INCLUDE
PAIN,TEARS, SWELLING, REDNESS AND BLURRED VISION. INGESTION:
INGESTION MAY RESULT IN NAUSEA, VOMITING, DIARRHEA.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FOR DIRECT CONTACT, FLUSH THE AFFECTED EYE(S)
WITH CLEAN WATER FOR 15 MINUTES OR UNTIL IRRITATION SUBSIDES. IF
IRRITATION OR REDNESS PERSISTS, SEEK MEDICAL ATTENTION. SKIN
CONTACT: CLEANS E AFFECTED AREA(S) THOROUGHLY BY WASHING WITH MILD
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. INHALATION
(BREATHING): SINCE THIS MATERIAL IS NOT EXPECTED TO BE AN IMMEDIATE
INHALTION PROBLEM, NO FI RST AID PROCEDURES ARE REQUIRED. INGESTION
9SWALLOWING): IF SWALLOWED, GIVE WATER OR MILK TO DRINK AND
DIRECTED TO DO SO BY MEDICAL PERSON NEL.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:>550.C, 1022.F
Extinguishing Media:NON-FLAMMABLE.
Fire Fighting Procedures:AFTER WATER EVAPORATES, REMAINING MATERIAL
WILL BURN. USE ALCOHOL-TYPE OR UNIVERSAL-TYPE FOAMS APPLIED BY
MANUFACTURERS' RECOMMENDED TECHNIQUES FOR LARGE FIRES. CARBON
DIOXIDE OR DRY CHEMICAL FOR SMAL L FIRES.
Unusual Fire/Explosion Hazard:THIS MATERIAL WILL NOT BURN. HOWEVER,
DEHYDRATED RESIDUE WILL BURN. NORMAL COMBUSTION FORMS CARBON
DIOXIDE AND WATER VAPOR.
================== Accidental Release Measures ==================
Spill Release Procedures:BEFORE HANDLING A SPILL, ALWAYS OBSERVE THE
SAFETY PRECAUTIONS DESCRIBED IN CONTROL MEASURES. SPILLS CAN BE
REMOVED WITH A SUITABLE ABSORBED (I.E., SAND OR SAWDUST). THE REST
CAN BE REMOVED WITH WATER .
======================Handling and Storage ======================
Other Precautions:EXPOSURE-THIS PRODUCT CONTAINS POTASSIUM SALTS WHICH
IS AN ACUTE RISK. INGESTION OF LARGE AMOUNTS (25 OR MORE GRAMS) OF
POTASSIUM SALTS USUALLY CAUSE A PERSON TO VOMIT. IF THE PERSON IS
NOT SUFFERING FROM A PRE-EXISTING KIDNEY &/OR CARDIAC CONDITION,
THE ABSORBED POTASSIUM SALTS IS EXCRETED IN THE U RINE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION IS NORMALLY
REQUIRED.
Ventilation:NO SPECIAL VENTILATION IS NECESSARY..
HANDLED IS ADVISED.
EYE CONTACT
Other Protective Equipment:IT IS SUGGESTED THAT A SOURCE OF CLEAN WATER
BE AVAILABLE IN WORK AREA FOR FLUSHING EYES AND SKIN. IMPERVIOUS
CLOTHING SHOULD BE WORN AS NEEDED.
Supplemental Safety and Health
PRODUCT IDENTITY: TAD 45 RUNWAY DEICER.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:=116.1C, 241.F
Melt/Freeze Pt:>-60.C, -76.F
Vapor Pres:NDA
Vapor Density:NDA
pH:9-10.5
Viscosity:6.5 CP@20C
Solubility in Water:COMPLETE
Appearance and Odor:BLUE, NEARLY SCENTLESS.
Percent Volatiles by Volume:NDA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG ACIDS OR STRONG OXIDIZING AGENTS, SUCH AS
CHLORATES, NITRATES, PEROXIDES, ETC.
Stability Condition to Avoid:STABLE
Hazardous Decomposition Products:NONE KNOWN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:ACUTE ORAL TOXICITY LD50=5000 MG/KH (RATS).
SKIN IRRITATION: NON-IRRITANT. EYE IRRITATION: NON-IRRITANT. FISH
TOXICITY LC50> 500 MG/L (FATHEAD MINNOW). THIS MATERIAL IS
TOXICOLOGICALLY HARMLESS AND IS NOT A CARCINOGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL REGULATIONS AT
GOVERNMENT APPROVED INCINERATOR OR WASTE MANAGEMENT SITE.
===================== Regulatory Information =====================
SARA Title III Information:SARA SECTION 301-304: N/A. SARA SECTION
3110-0313: N/A. CERCLA SECTION 102: N/A.
Federal Regulatory Information:THIS PRODUCT IS NOT A HAZARD AS DEFINED
BY OSHA COMMUNICATIONS STANDARD (29 CFR SECTION 1910.1200). BASE
INGREDIENT IS LISTED IN TSCA INVENTORY.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VARCO BRIGHT, VO3502
CAGE:23112
CAGE:23112
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: <4%
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: <6%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:CONTACT WITH EYES AND SKIN WILL
IRRITATE AND BURN. INGESTION MAY CAUSE HEADACHE, NAUSEA, VOMITING
AND WEAKNESS. ANIMAL STUDIES HAVE CLEARLY DEMONSTRATED DOSE-RELATED
ADVERSE EFTS ON THE CNS, HEM ATOPOIETIC TISS, BLOOD, KIDNEYS &
LIVERASSOC W/ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE). (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:(EXTRACTED FROM DHHS (NIOSH) PUB NO.
90-118) .
Medical Cond Aggravated by Exposure:UNKNOWN.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
ATTENTION. SKIN:WASH WITH PLENTY OF SOAP AND WATER. INGEST:DRINK
PLENTY OF WATER. GET MEDICAL ATTENTION. INHAL:REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:170F,77C
Extinguishing Media:USUAL FIREFIGHTING MEDIA. MEDIA SUITABLE FOR
SURROUNDING FIRE .
Fire Fighting Procedures:NOT APPLICABLE. WEAR NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. MOP OR WIPE UP.
FLUSH REMAINDER WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SPARKS, OPEN FLAME OR
HEAT.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:VENTILATE TO KEEP AIR BELOW TLV. NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:ANSI APPRVE EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:190F,88C
Spec Gravity:1.010 (H*2O=1)
pH:12.8
Evaporation Rate & Reference:ABOUT THE SAME
Solubility in Water:COMPLETE
Appearance and Odor:COLORED SCENTED LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM AND TIN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE OR CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:452 BIG D CONCENTRATED ROOM DEODORANT 10 OZ.
CAGE:FO584
CAGE:17122
CAGE:FO584
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 35%
Other REC Limits:350 PPM (CL)
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: <55%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: <55%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: <55%
Other REC Limits:800 PPM
OSHA PEL:800 PPM
ACGIH TLV:800 PPM; 9192
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5%
Other REC Limits:400 PPM
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:N-AMYL ACETATE (SARA III)
CAS:628-63-7
RTECS #:AJ1925000
Fraction by Wt: 1.8%
Other REC Limits:530 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION.
INGESTION/INHALATION: LOW TOXICITY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION/INGESTION: LOW TOXICITY. SKIN/EYES:
IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN/EYES: FLUSH W/WATER. INGESTION: GIVE LARGE AMOUNTS OF
WATER. DON'T INDUCE VOMITING. INHALATION: REMOVE TO FRESH AIR.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. KEEP
CONTAINERS COOL TO AVOID BURSTING.
Unusual Fire/Explosion Hazard:EXPOSURE TO TEMPERATURES >120F MAY CAUSE
BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:IF CONTAINER IS RUPTURED & BEGINS TO LEAK,
PLACE IN A WELL VENTILATED AREA & ELIMINATE ALL IGNITION SOURCES.
WASH SPILLS W/SOAP & WATER. FOR LARGE SPILLS SOAK UP W/INERT
ABSORBENT MATERIAL SUCH AS SAN D.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE NEAR HEAT OR OPEN FLAME.
STORE AS A LEVEL 2 AEROSOL.
Other Precautions:AVOID CONTACT W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED.
Ventilation:PROVIDE ADEQUATE LOCAL EXHAUST/MECHANICAL VENTILATION.
Other Protective Equipment:EYEWASH FACILITY
Work Hygienic Practices:GOOD HOUSEKEEPING PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:3625
Vapor Density:>1
Spec Gravity:1.25
Solubility in Water:5%
Appearance and Odor:VERY DRY SPRITZ W/VARIOUS FRAGRANCE ODORS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS NITRIC ACID
Stability Condition to Avoid:HEAT, OPEN FLAME
Hazardous Decomposition Products:HYDROGEN CHLORIDE & SMALL AMOUNTS OF
PHOSGENE & CHLORINE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. LANDFILL FOR ABSORBENT MATERIAL. DON'T
INCINERATE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DAPCO NO. 18-4 PART A
Kit Part:Y
Preparer's Name:N. ZARRABI
CAGE:OOOO8
CAGE:OOOO8
CAGE:58093
============= Composition/Information on Ingredients =============
Ingred Name:LEAD BEARING FRITS (59.2 % LEAD OXIDE)
CAS:65997-18-4
Fraction by Wt: 3.0%
Other REC Limits:NONE SPECIFIED
Ingred Name:LEAD AND CADMIUM FREE FRIT
CAS:65997-18-4
Fraction by Wt: 9.0%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN & EYES: LONG EXPOSURE OVER A LONG
PERIOD OF TIME MAY CAUSE SLIGHT IRRITATION. INGESTION: SMALL
AMOUNTS INGESTED DURING NORMAL HANDLING, MAY CAUSE STOMACH
DISCOMFORT. INHALATION: NOT A POSSIBLE RO UTE OF ENTRY.
Explanation of Carcinogenicity:LEAD MIGHT BE PRESENT IN THE LEAD OXIDE
CONTENT OF THE FRITS. CUMALATIVE LEAD EXPOSURE MAY CAUSE LEAD
POISONING.
Effects of Overexposure:SEE SECTION ON HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN. HOWEVER, PEOPLE WITH
ALLERGIES SHOULD TAKE EXTRA CARE HANDLING CHEMICALS.
======================= First Aid Measures =======================
First Aid:INHALATION: NO PROBLEM IS ANTICIPATED. SKIN & EYES: WASH
THOROUGHLY WITH WATER. SHOULD IRRITATION PERSIST GET MEDICAL
ATTENTION. INGESTION: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>400F,>204C
Extinguishing Media:SELF EXTINGUISHING, FIRE RESISTANT. IN VERY RARE
CASES THAT THE FIRE PERSISTS, USE CARBON DIOXIDE OR FOAM.
Fire Fighting Procedures:PROPER PROTECTIVE CLOTHING WITH BUILT IN
BREATHING APPARATUS MUST BE WORN, WHEN FIGHTING ANY FIRES INVOLVING
CHEMICALS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE, SCRAPE OR SOAK IN ANY INERT MATERIAL AND
PUT AWAY IN A CONTAINER FOR DISPOSAL. CLEAN THE WALKWAYS TO AVOID
SLIPPING. IF CLEANING SOLVENTS WERE USED, PROPER VENTILATION IS
REQUIRED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY SEALED CONTAINERS
AWAY FROM CURE INHIBITANTS SUCH AS GREASE, DUST AND ANY OTHER
CHEMICALS.
Other Precautions:NONE KNOWN
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:LOCAL EXHAUST, GENERAL MECHANICAL
Other Protective Equipment:RUBBER APRON TO PROTECT THE CLOTHING
Work Hygienic Practices:THIS IS A SAFE PRODUCT TO HANDLE, EXERCISE THE
NORMAL INDUSTRIAL HOUSEKEEPING.
Supplemental Safety and Health
KEY1:N1. THIS ENTRY DESCRIBES PART A OF A TWO PART KIT. SEE THIS SAME
NSN, P/N IND B, FOR PART B DATA.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>500F,>260C
Vapor Pres:NEGLIGIBLE
Vapor Density:NEGLIGIBLE
Spec Gravity:1.32
Evaporation Rate & Reference:1 (BU AC = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK OLIVE GREEN PASTE, WITH NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS MAY CAUSE SOME REACTIONS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO, CO2, SIO2
==================== Disposal Considerations ====================
Waste Disposal Methods:CURE PART A & B AND DISPOSE OF AS AN INERT
MATERIAL. ALL DISPOSALS MUST COMPLY WITH LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:702 ARMOUR PLATE LIQUID ROOF COATING
Preparer's Name:PHILLIP S. HOWARD, CSP
CAGE:TROPI
CAGE:TROPI
============= Composition/Information on Ingredients =============
Ingred Name:ASPHALT BASE
CAS:8052-42-4
RTECS #:CI9900000
Other REC Limits:C 10 MG/M3
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:VOLATILE PETROLEUM SOLVENTS
CAS:8030-30-6
RTECS #:DE3030000
OSHA PEL:400 MG/M3;100 PPM
ACGIH TLV:300 MG/M3
Ingred Name:FIBERS, NATURAL (NON ASBESTOS)
ACGIH TLV:10 MG/M3 AS DUST
Ingred Name:FIBERS, SYNTHETIC
ACGIH TLV:10 MG/M3 DUST
Ingred Name:FIBERS, ASBESTOS
CAS:1332-21-4
RTECS #:CI6475000
OSHA PEL:0.2 FIBER/CC
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:(CARCINOGEN AS RAW MATERIAL ONLY)
Fraction by Wt: NOTE ONLY
Other REC Limits:NO FRIABLE FIBERS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: ITCHING, UNCONSCIOUSNESS,
DIZZY, DRY SKIN, NAUSEA. CHRONIC: DIFFICULT BREATHING. REPEAT
AND/OR CONTINUED EXPOSURE CAN = CHEMICAL PNEUMONIA, LIVER/ KIDNEY
DAMAGE.
Explanation of Carcinogenicity:CANCER STUDIES-NO FRIABLE FIBERS.
Effects of Overexposure:ITCHING, UNCONSCIOUSNESS, DIZZY, DRY SKIN,
NAUSEA, DIFFICULT BREATHING, CHEMICAL PNEUMONIA, LIVER/KIDNEY
DAMAGE.
Medical Cond Aggravated by Exposure:REPEATED/CONTINUOUS EXPOSURE CAN
AGGRAVATE EMPHYSEMA.
======================= First Aid Measures =======================
First Aid:LARGE AMOUNTS MAY NEED EMERGENCY TREATMENT. INHALATION: GET
TO FRESH AIR, ADMINISTER OXYGEN OR ARTIFICIAL RESPIRATION. EYES:
FLUSH EYES FOR 15 MINUTES WITH CLEAN WATER, GET MEDICAL ATTENTION.
SKIN: WA SH WITH SOAP AND WATER. GET MEDICAL CARE IF IRRITATION
PERSISTS. INGESTION: DO NOT INDUCE VOMITING, GET MEDICAL ATTENTION
QUICKLY.
===================== Fire Fighting Measures =====================
Flash Point:>37.8C, 100.F
Autoignition Temp:>204.4C, 400.F
Lower Limits:0.9
Upper Limits:6.0
Extinguishing Media:DRY CHEMICAL, FOAM, WATER FOG.
Unusual Fire/Explosion Hazard:PETROLEUM BASED COMPOUNDS CAN FLOAT ON
WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE NON-SPARKING TOOLS, SHOVEL UP AND PLACE IN
CLOSED CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE IN WELL VENTILATED AREA; STORE IN
DRY, COOL AREA.
DO NOT HEAT FOR APPLICATION. WASH CONTAMINATED CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC VAPOR CARTRIDGE IF IN AN ENCLOSED AREA.
Ventilation:IF INSIDE: LOCAL EXHAUST AND MECHANICAL/GENERAL VENTILATION
RECOMMENDED.
Other Protective Equipment:WEAR LONG SLEEVE SHIRT AND LONG PANTS
RECOMMENDED. DO NOT HEAT FOR APPLICATION. WASH CONTAMINATED
CLOTHING.
IRRITATION. WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:=156.1C, 313.F
Melt/Freeze Pt:M.P/F.P Text:N/F
Vapor Pres:N/F
Vapor Density:N/F
Spec Gravity:>1.0
Evaporation Rate & Reference:N/F(BUAC=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK COLOR, HEAVY VISCOUS LIQUID; PETROLEUM ODOR.
Percent Volatiles by Volume:<60%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, CAUSTRICS, OXIDIZERS.
Stability Condition to Avoid:KEEP FROM HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:NITROGEN OXIDES, CARBON OXIDES.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:CARCINOGEN AS RAW MATERIAL ONLY. PRODUCT HAS
NO FRIABLE FIBERS.
==================== Disposal Considerations ====================
Waste Disposal Methods:RCRA REGULATED MATERIAL. CONSULT LOCAL, STATE
AND FEDERAL REGULATION FOR PERMITTED LAND FILL DISPOSAL OR
INCINERATION.
===================== Regulatory Information =====================
Federal Regulatory Information:RCRA REGULATED MATERIAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CS 3204 PART B
Kit Part:Y
Preparer's Name:HERBERT MOORE
CAGE:14439
CAGE:14439
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE DIOXIDE
CAS:1313-13-9
RTECS #:OP0350000
Fraction by Wt: 65%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG MN/M3
ACGIH TLV:5 MG MN/M3
Ingred Name:VOC: 1 GM/LITER
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IMPAIRMENT OF CENTRAL NERVOUS SYSTEM
(CNS).
Effects of Overexposure:SLUGGISHNESS, SLEPPLESSNESS AND/OR WEAKNESS IN
THE LEGS.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER, CONTACT A PHYSICIAN.
SKIN: WASH WITH SOAP & WATER.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:DRY CHEMICAL, CO2, FOAM, WATER
Fire Fighting Procedures:IN CONFINED AREAS WEAR SELF-CONTAINED
BREATHING APPARATUS (SCBA).
Unusual Fire/Explosion Hazard:EXPLOSION HAZARD IF HEATED WITH
OXIDIZABLE MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP AND TRANSFER TO SAFETY CONTAINER,
WASH SURFACE WITH SOAP & WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY AREA.
Other Precautions:WASH HANDS BEFORE EATING, DRINKING OR SMOKING AFTER
HANDLING THIS PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED
Other Protective Equipment:APPROPRIATE TO PREVENT PROLONGED CONTACT
WITH SKIN.
Work Hygienic Practices:TRAIN PERSONNEL IN SAFE HANDLING OF THIS
PRODUCT.
Supplemental Safety and Health
KEY1:N1.
================== Physical/Chemical Properties ==================
HCC:F4
Melt/Freeze Pt:M.P/F.P Text:LIQ@RM TEMP
Spec Gravity:2.0 WATER = 1
pH:9.0
Viscosity:1000 POISES
Evaporation Rate & Reference:NIL (BUTYL ACETATE = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK PASTE, OILY ODOR
Percent Volatiles by Volume:2.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCING AGENTS AND COMBUSTABLES, H2S, POTASSIUM AZIDE.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO2, CO, NO, NO2, DUST
==================== Disposal Considerations ====================
Waste Disposal Methods:REACT WITH BASE COMPONENT & DISPOSE AS SOLID
WASTE ACCORDING TO LOCAL, STATE & FEDERAL REGULATIONS. INDINERATION
&/OR LANDFILL-MIXED WITH PART A, HAZARDOUS WASTE. PART B ALONE
NON-HAZARDOUS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PLASTISOL
CAGE:8L872
CAGE:8L872
============= Composition/Information on Ingredients =============
Ingred Name:RESIN (COMBINED WITH STABILIZERS & PLASTICIZERS, FORMS 98%
OF THE PRODUCT)
Ingred Name:PLASTICIZERS
Ingred Name:STABILIZERS
===================== Hazards Identification =====================
Effects of Overexposure:EXCESS HIGH TEMP MAY PRODUCE IRRITAT VAPOR.
SHOULD BE EXHAUSTED
======================= First Aid Measures =======================
First Aid:WASH SKIN W/SOAP&WATER . WASH EYES WITH WATER. REMOVE TO
FRESH AIR
===================== Fire Fighting Measures =====================
Flash Point:425F COC
Extinguishing Media:DRY POWDERS, CO*2, CHEMICAL FOAMS, WATER FOG
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:MFR SUGGESTS TREATING AS NON-HAZARDOUS LIQUID
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 90F TO AVOID SPOILING
MATEIAL
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NECESSARY (MFR)
Ventilation:MFR RECM LOCAL EXHAUST DURING PROCESSING
Supplemental Safety and Health
PHYSICAL DATA PERTAINS TO MOST VOLATILE INGRED OF COMPOSITION. MFR
SUGGESTS TLV OF 5MG/CUM (ACGIH), VAPOR PRESSURE: 1.2 AT 200 C.
PRODUCT IS A VINYL PLASTISOL
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:386C
Vapor Density:16
Spec Gravity:0.98
Evaporation Rate & Reference:<0.1 (BU AC)
Solubility in Water:NEGLIGIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:SMOKE,SOOT,CO,CO*2,& ALL VAPOR WHEN
BURNED
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECM SAME AS MOTOR OIL. DISPOSE OF IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL CODES
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:709972 TYPE B STARMAT DEVLPR & REPL,PART A
Kit Part:Y
Preparer's Name:OLIN MSDS CONTROL GROUP
CAGE:73877
CAGE:73877
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
Fraction by Wt: 10-15%
Other REC Limits:NONE SPECIFIED BY M.
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED BY M.
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HYDROQUINONE (SARA III)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED BY M.
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SODIUM TETRABORATE, DECAHYDRATE
CAS:1303-96-4
RTECS #:VZ2275000
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED BY M.
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3; 9293
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO
Health Hazards Acute and Chronic:ACUTE-EYES/SKIN:IRRITATION, MAY DAMAGE
EYES. INHALATION:IRRITATION. INGESTION:MAY BE HARMFUL.
CHRONIC-SKIN:IRRITATION/ALLERGIC REACTION.
Effects of Overexposure:SKIN AND EYE IRRITATION, REDNESS AND PAIN IN
THE EYES., VOMITING AND DIARRHEA.
Medical Cond Aggravated by Exposure:NONE NOTED.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR, PROVIDE CPR/OXYGEN IF NEEDED.
EYE CONTACT:FLUSH WITH WATER FOR 15 MINUTES. GET MEDICAL HELP. SKIN
CONTACT:WASH WITH SOAP AND WATER. GET MED ATTENTION IF SYMPTOMS
PERSIS T. INGESTION: DRINK 1-2 GLASSES OF WATER. GET MEDICAL HELP
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM OR CARBON DIOXIDE
Fire Fighting Procedures:WEAR SCBA. USE WATER SPRAY TO COOL FIRE
EXPOSED CONTAINERS AND TO DISPOSE VAPORS.
Unusual Fire/Explosion Hazard:NONE NOTED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PRTECTIVE EQUIPMENT. ADD DRY ABSORBENT
AND PLACE IN AN APPROPRIATE DOT CONTAINER AND SEAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:AVOID SKIN CONTACT.DO NOT BREATHE MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NEEDED
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:RUBBER APRON.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE AND
LAUNDER CONTAMINATED CLOTHING.
Supplemental Safety and Health
THIS IS PART A OF A 3-PART KIT. FOR PARTS B AND C, SEE PNI B AND C, OR
PART E AND F, SAME NSN. PART A CAT # 709972. WHOLE KIT # 810838.
================== Physical/Chemical Properties ==================
HCC:C2
Boiling Pt:=100.C, 212.F
Vapor Pres:15 MMHG
Spec Gravity:1.27
pH:11.5
Evaporation Rate & Reference:1.0 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:AQUEOUS SOLUTION.
Percent Volatiles by Volume:55
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES,OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:METAL OXIDES AND OXIDES OF SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF CONTAMINATED PRODUCT,EMPTY CONTAINERS
AND MATERIAL USED IN CLEANING UP SPILLS OR LEAKS IN A MANNER
APPROVED FOR THIS MATERIAL.CONSULT APPROPRIATE FEDERAL,STATE AND
LOCAL REGULATORY AGENCIES TO ASCERTAIN PROPER DISPOSAL PROCEDURES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:#1000 BLACK CONCENTRATE
CAGE:39739
CAGE:39739
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-BUTOXY-; (BUTYL CELLOSOLVE) (EGBE)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 66%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S
Ingred Name:ETHYLENE GLYCOL
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 9%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM, VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 25%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACID BLACK 2; (BLACK DYE)
CAS:8005-03-6
Fraction by Wt: TRACE
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HEADACHES, NAUSEA, NARCOSIS.
CHRONIC: NOT APPLICABLE ANIMAL STUDIES HAVE CLEARLY DEMONSTRATED
DOSE-RELATED ADVERE EFTS ON CNS, HEMATOPOIETIC TISSUE, BLOOD,
KIDNEYS & LIVER ASSOC W/ADMIN OF ETHY LENE GLYCOL MONOBUTYL ETHER
(EGBE). (EXTRACTED FROM DHHS (NIOSH) PUB # 90-118) .
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR, CONSULT PHYSICIAN EYES: FLUSH
W/WATER FOR AT LEAST 15 MINUTES, CONSULT PHYSICIAN. SKIN: WASH WITH
WATER. INGEST: DRINK LARGE QTY OF WATER. INDUCE VOMITING, CONSULT
PHYSICIA N.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLASHING
Extinguishing Media:CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER, CLEAN UP WITH ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:YES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:310F,154C
Vapor Pres:20
Vapor Density:<1
Spec Gravity:1(H*2O=1)
Solubility in Water:COMPLETELY MISCIBLE
Appearance and Odor:BLACK, ODORLESS
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS AND ALKALIES.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION. DISPOSE OF I/A/W FEDERAL, STATE
AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SSS AEROSOL SOLVENT SPOTTER, 390-351
CAGE:HO359
CAGE:51130
CAGE:HO359
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 3%
OSHA PEL:200 PPM;150 STEL
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOPROPYL ALCOHOL; (ISOPROPANOL)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 15%
OSHA PEL:400 PPM;500 STEL
ACGIH TLV:400 PPM;500 STEL
Ingred Name:ETHYLENE, TETRACHLORO-; (PERCHLOROETHYLENE)
CAS:127-18-4
RTECS #:KX3850000
Fraction by Wt: 50%
OSHA PEL:100 PPM
ACGIH TLV:25 PPM;100 STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ETHANE, 1,1,1-TRICHLORO-; (1,1,1-TRICHLOROETHANE)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 29%
OSHA PEL:350 PPM;450 STEL
ACGIH TLV:350 PPM;450 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN & EYE:MAY CAUSE IRRITATION.
INGEST:MAY CAUSE STOMACH DISTRESS, NAUSEA OR VOMITING. NOTE:TOLUENE
APPEARS ON THE NAVY LIST OF OCCUPATIONAL CHEMICAL REPRODUCTIVE
HAZARDS. SEEK CONSULTATION FROM APPR OPRIATE HEALTH PROFESSIONALS
CONCERNINGLATEST HAZARD LIST INFO & SAFE HANDLING & EXPOS INFO .
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CHLOROCARBON MATLS HAVE PRODUCED
SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE
SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS (E.G. EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FORLIFE-SUSTAINING USES IN HUMANS ACUTELY
OR CHRONICALLY EXPOSED TO CHLOROCARBONS .
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . EYES:FLUSH IMMEDIATELY FOR AT LEAST 15 MINUTES W/WATER,
REMOVE CONTACT LENSES. SKIN:FLUSH W/SOAP & WATER. INGEST:RINSE
MOUTH, THEN DRINK 1 OR 2 LARGE GLASSES OF WATER. DO NOT INDUCE
VOMITING. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Lower Limits:8%
Upper Limits:10.5%
Extinguishing Media:COLD WATER SPRAY SHALL REDUCE VAPOR PRESSURE IN
CONTAINER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA &
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMP PRODUCTS MAY INCL HCL &
PHOSGENE . CONTENTS UNDER PRESS, HEAT MAY CAUSE BURSTING OF CANS.
CANS MAY RUPTURE & CONTENTS RELEASED (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PROTECTIVE EQUIPMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY, COOL PLACE. KEEP OUT OF
REACH OF CHILDREN. KEEP AWAY FROM STOVES, FURNACES & DIRECT
SUNLIGHT. DO NOT PUNCTURE OR INCINERATE.
Other Precautions:NO SMOKING IN AREAS OF USE. DO NOT USE IN GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV
RADIATION MAY CAUSE THE FORMATION OF HCL &/OR PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:MECHANICAL VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:104F,40C
Vapor Density:4.3
Spec Gravity:1.3 (H*2O=1)
Evaporation Rate & Reference:0.62 (BUTYL ACETATE=1)
Solubility in Water:1.3
Appearance and Odor:CLEAR LIQUID; STRONG CLEANING FLUID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXGYEN, ALKALI METALS, OPEN FLAME.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AT HIGH TEMPS, DECOMPOSES TO GIVE OFF
HYDROGEN CHLORIDE VAPOR & SMALL AMOUNTS OF TOXIC VAPORS SUCH AS
PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT FEDERAL, STATE & LOCAL AUTHORITIES FOR
RESTRICTIONS ON DISPOSAL OF CHEMICAL WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:872 9626 CANVAS WIDE FORMAT INKJET MEDIA
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS CANVAS BASE
Fraction by Wt: 95-99%
Other REC Limits:NONE RECOMMENDED
Ingred Name:OTHER ADDITIVES
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT IS NOT EXPECTED TO CAUSE
ANY HEALTH OR SAFETY HAZARDS WHEN USED AS INTENDED. INKJET MEDIA
ARE NOT HAZARDOUS TO HEALTH.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:NONE SPECIFIED BY MANUFACTURER.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:NONFLAMMABLE. USE STANDARD FIREFIGHTING
PROCEDURES FOR SURROUNDING MATERIALS IN THE FIRE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT FOR REUSE/DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:THIS PRODUCT IS NOT EXPECTED TO CAUSE
ANY HEALTH OR SAFETY HAZARDS WHEN USED AS INTENDED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:NONE SHOULD BE NEEDED.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:NOT GIVEN
Viscosity:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:NOT GIVEN
Appearance and Odor:INKJET MEDIA
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL OR DISPOSE IN ACCORDANCE WITH LOCAL,
STATE OR FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:98-53 CADILLAC BLUE SPRUCE 473
CAGE:59581
CAGE:59581
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Other REC Limits:50 PPM
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 9-32%
Other REC Limits:590 MG/CUM
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:MINERAL SPIRITS
CAS:64742-86-7
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 4-15%
Other REC Limits:100 PPM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
Other REC Limits:STEL 400 PPM
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Other REC Limits:100 PPM
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITANT. SKIN:
DEFATTING/DERMATITIS/SCALY/REDNESS/DRY/ABSORPTION. INHALATION:
RESPIRATORY SYSTEM IRRITATION/HEADACHE/DIZZINESS/NAUSEA/POSSIBLE
UNCONSCIOUSNESS/ASPHYXIATION/NOSE/THROAT IRRITATION
/NAUSEA/VOMITING/INCOORDINATION/DROWSINESS. INGESTION:
STUPER/INTOXICATION/COMA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: CARDIAC EFFECTS/CNS
DEPRESSION/PERIPHERAL POLYNEUROPATHY/COMA/HARMFUL/FATAL. INGESTION:
HARMFUL/FATAL. EYES: IRRITATION. SKIN IRRITATION & FISSURED
DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING STOPS, BEGIN
ARTIFICIAL RESPIRATION. EYES: FLUSH W/WATER FOR 15 MINUTES. SKIN:
WASH W/SOAP & WATER. INGESTION: UNLIKELY FROM AN AEROSOL CAN.
OBTAIN MEDICA L ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:-10F
Lower Limits:0.70%
Upper Limits:9.5%
Extinguishing Media:USE CO2, DRY CHEMICAL & FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS
KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT OR SUN MAY CAUSE
BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. WIPE UP W/INERT MATERIALS &
PLACE IN APPROPRIATE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. EXPOSURE TO HEAT OR
PROLONGED EXPOSURE TO SUN MAY CAUSE BURSTING.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING
VAPORS & INHALING CONTENTS CAN BE HARMFUL OR FATAL. USE ONLY AS
DIRECTED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A SELF-CONTAINED BREATHING APPARATUS
REQUIRED FOR CONCENTRATIONS >TLV.
Ventilation:ADEQUATE VENTILATION IS SUFFICIENT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:40 PSIA
Vapor Density:>AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:PAINT W/SOLVENT ODOR
Percent Volatiles by Volume: 85%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:TEMPS >120F, SPARKS, PILOT LIGHT, OPEN
FLAME, SOURCES OF IGNITION, HEAT & SUNLIGHT
Hazardous Decomposition Products:CO2 & CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T INCINERATE AEROSOL CAN, DISPOSE OF IN
ACCORDANCE W/LOCAL STATE & FEDERAL REGULATIONS. DON'T PLACE AEROSOL
CANS IN HOME COMPACTOR. DON'T PUNCTURE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DIVINYLBENZENE 55
CAGE:GO743
CAGE:96717
CAGE:GO743
============= Composition/Information on Ingredients =============
Ingred Name:DIVINYLBENZENE(META AND PARA) 50-60 %
CAS:108-57-6
RTECS #:CZ9450000
Fraction by Wt: 60.0%
ACGIH TLV:10 PRM
Ingred Name:ETHYLVINYLBENZENE PLUS DIETHYLBENZENE,40-50 %.
Fraction by Wt: 40.0%
===================== Hazards Identification =====================
Effects of Overexposure:EYES:MILD IRRITATION.NASAL IRRITATION,POSSIBLE
DIZZINESS & DRUNKENESS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER FOR 5 MIN.SKIN:WASH W/WATER.CALL
DR.INHAL:MOVE TO FRESH AIR.CALL DR. RESTORE BREATHING IF
NEEDED.INGEST:DO NOT VOMIT.
===================== Fire Fighting Measures =====================
Flash Point:150F
Lower Limits:0.80
Upper Limits:5.50
Extinguishing Media:AFFF FOAM(CONSIDERED MOST EFFECTIVE)PROTEIN
FOAM,CO*2,D.CHEM
Fire Fighting Procedures:COOL STORAGE CONTAINERS USING WATER IF EXPOSED
TO FIRE.
Unusual Fire/Explosion Hazard:POSSIBLE COMBUSTION
PROD:ALKYLBENZENES,VINYLBENZENES,NAPHTHALENE,BENZALDEHYDES,PHENOL,C
ARBON DIOZIDE
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL:ABSORB WITH IMBIBER BEADS OF WITH
SAND.DO NOT USE ZORBALL.LARGE SPILL:DIKE & PUMP WATER INTO
AREA.PUMP OFF DIVINYLBENZENE TO BE BURNED OR PURIFIED.
======================Handling and Storage ======================
Handling and Storage Precautions:PRAXTICE REASONABLE CARE &
CAUTION.AVOID BREATHING VAPORS IF GENERATED.MAINTAIN INHIBITOR
LEVEL.
Other Precautions:IF INHIBITOR IS TBC,THE MONOMER SHOULD BE AERATED
1/WK FOR 30 MINUTES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATORY;EMERTENCIES:A
SELF-CONTAINED BREATHING EQ
Ventilation:RECOMMEND CONTROLS OF VAPOR TO SUGGESTED GUIDES.
Other Protective Equipment:EYE FOUNTAIN & SAFETY SHOWERS,FULL-FACE
RESPIRATOR(NIOSH).
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:383F.
Vapor Pres:0.9
Vapor Density:4-5
Spec Gravity:0.9084
Solubility in Water:0.0052%
Appearance and Odor:LIQUID,YELLOWISH-CLEAR,HYDROCARBON ODOR
Percent Volatiles by Volume:100.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACID,BASE,OXIDIZING MATERIAL
Stability Condition to Avoid:STORE BELOW 90F.MAINTAIN INHIBITOR LEVEL.
Hazardous Decomposition
Products:ALKYLBENZENES,VINYLBENZENES,NAPHTHALENE,BENZALDEHYDES,PHEN
OL
Conditions to Avoid Polymerization:AVOID HEAT,METAL SALTS(SUCH AS
FERRIC ALUMINUM CHLORIDE).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF DIVINYLBENZENE 55 MUST MEET ALL
FEDERAL,STATE,AND LOCAL REGULATIONS, CONTACT THE DOW CHEMICAL
COPMANY FOR FURTHER INSTRUCTIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SELECTRON PALLADIUM(EG), SPS 5735
CAGE:FO860
CAGE:FO860
CAGE:11924
============= Composition/Information on Ingredients =============
Ingred Name:1,2-ETHANEDIAMINE; (ETHYLENEDIAMINE)
CAS:107-15-3
RTECS #:KH8575000
Fraction by Wt: <8%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NONHAZARDOUS INGREDIENTS
Fraction by Wt: <92%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: ETHYLENEDIAMINE VAPORS MAY
CAUSE IRRITATION OF EYES, NOSE AND THROAT. CAN CAUSE BLISTERING OF
SKIN AND POSSIBLE SKIN DAMAGE. CHRONIC: MAY CAUSE DERMATITIS OVER
PROLONGED PERIOD OF TIME. ALLERGI C REACTION CAN OCCUR. IRRITATION
AND SENSITIZATION OF THIS MATERIAL MAY BE EVIDENT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:REPEATED EXPOSURE TO THIS MATERIAL
W/OUT PROPER SAFETY PRECAUTIONS MAY CAUSE LIVER, KIDNEY AND LUNG
DAMAGE.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SKIN: FLUSH W/COLD WATER. IF
IRRITATION DEVELOPS AND/OR PERSISTS, CONSULT A PHYSICIAN. EYES:
FLUSH W/COLD WATER FOR AT LEAST 15 MINUTES. CONSULT A PHYSICIAN.
INGEST: GIVE L ARGE QTY OF WATER AND INDUCE VOMITING. CONSULT A
PHYSICIAN IMMED. A PHYS SHOULD BE CONTACTED IF ANYONE DEVELOPS
SYMPS OF OVEREXPOSURE TO ETHYLENEDIAMINE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NO RESTRICTIONS. MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DECOMPOSITION PRODUCTS CAN BE TOXIC
(AMINES, CARBON MONOXIDE AMMONIA).
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH AN INERT MATERIAL AND REMOVE TO A
DISPOSAL AREA IF APPLICABLE. VENTILATE AREA. CANNOT BE FLUSHED TO
ANY SEWER OR DRAIN.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:SAFETY SHOWERS AND EYEWASH STATIONS
SHOULD BE PROVIDE FOR EMERGENCY USE.
Other Precautions:IF CLTHG SHOULD BE SPLASHED/CONTAMD W/PROD, IT SHOULD
BE DRENCHED W/WATER & NOT WORN AGAIN UNTIL LAUNDERED.
EATING/SMOKING SHOULD NOT BE PERMITTED IN AREAS WHERE MATL IS
HNDLD. PROPER TRAINING SHOULD BE GIVEN TO EMPLOYEES HNDLG THIS
MATL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUST, MIST AND FUME
RESPIRATOR, 3M #9920.
Ventilation:LOCAL EXHAUST: ADEQUATE EXHAUST.
Other Protective Equipment:SAFETY SHOWERS & EYEWASH STATIONS SHOULD BE
PROVIDE FOR EMERGENCY USE. USE ANY OTHER EQUIP SO AS NOT TO SPLASH
ON SKIN.
Work Hygienic Practices:EMPLOYEES WHO HANDLE MATL SHOULD WASH THEIR
HANDS & FACE THORO BEFORE EAT, SMOKING/USING REST ROOM FACILITIES.
Supplemental Safety and Health
HYGIENE PRACT: EATING AND SMOKING SHOULD NOT BE PERMITTED IN AREAS
WHERE MATL IS HNDLD. PROPER TRAINING SHOULD BE GIVEN TO EMPLOYEES
HNDLG THIS MATERIAL. EYE PROT: FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.10(H*2O=1)
pH:8.1
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW COLOR SOLUTION, SLIGHT AMMONIA ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS, OXIDIZERS AND CHLORINATED COMPOUNDS.
Hazardous Decomposition Products:OXIDES OF NITROGEN AND CARBON MONOXIDE
MAY BE RELEASED IN A FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:MUST BE DISPOSED OF I/A/W STATE, LOCAL AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BUTYL RUBBER CAULK
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED LIGHT PETROLEUM DISTILLATE
CAS:64742-47-8
Fraction by Wt: 15% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:TALC (CONTAINING ASBESTOS)
CAS:14807-96-6
RTECS #:MW2700000
Fraction by Wt: < 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBERS/CC; 9394
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: < 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9394
Ingred Name:NON HAZARDOUS INGREDIENTS
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME
OVEREXPOSURE MAY RESULT IN UNCONSCIOUSNESS, DEATH. PROLONGED
OVEREXPOSURE MAY CAUSE INJURY TO THE LIVER, U RINARY TRACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:HEADACHE, DIZZINESS, NAUSEA, LOSS OF
COORDIANTION, REDNESS & ITCHING OR BURNING OF EYES AND/OR SKIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. GET MEDICAL ATTENTION. SKIN: WASH AFFECTED AREA
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION.EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:105F,41C
Lower Limits:1.0 %
Upper Limits:NOT GIVEN
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY
CAUSE A HEALTH HAZARD. SYMPTOMS MAY BE DELAYED.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE FLAMMABLE. KEEP AWAY FROM
HEAT, SPARKS AND OPEN FALME. KEEP AREA VENTILATED. DO NOT SMOKE.
KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DURING USE AND UNTIL ALL VAPORS ARE GONE: EXTINGUISH
ALL FLAMES, PILOT LIGHTS AND HEATERS. TURN OFF STOVES, ELECTRIC
TOOLS AND APPLIANCES, AND OTHER SOURCES OF IGNITION. APPLICATION TO
HOT SURFACES RE QUIRES SPECIAL PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS PER
CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND NIOSH RESPIRATOR
SELECTION.
Ventilation:LOCAL EXHAUST PREFERRABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE TO MATERIALS IS MAINTAINED BELOW TLVS.
Other Protective Equipment:WHEN SANDING, WIREBRUSHING, ABRADING,
BURNING OR WELDING THE DRIED FILM, WEAR A PARTICULATE RESPIRATOR.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
DO NOT TAKE INTERNALLY. USE APPROVED BONDING AND GROUNDING PROCEDURES.
KEEP OUT OF REACH OF CHILDREN. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND I
NHALING THE CONTENTS CAN BE HARMFUL OR FATAL.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:300-395F
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:> 1
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:NOT GIVEN
Appearance and Odor:PASTE, MINERAL SPIRITS ODOR
Percent Volatiles by Volume:27 %
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT,
SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: PEEL AWAY I
Cage: 0ZTD8
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 0ZTD8
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE: MAY CAUSE SEVERE BURNS - POSSIBLE PERMANENT DAMAGE.
SKIN: CHEMICAL BURNS WITH REDDENING AND PAIN, DERMATITIS. INHALATION: EYE AND
RESPIRATORY IRRITATION. INGESTION: BURNS TO MOUTH, GASTROINTESTIN AL
CORROSION.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: INDIVIDUALS WITH CHRONIC RESPIRATORY OR
SKIN DISEASES MAY BE AT INCREASED RISK FROM EXPOSURE.
First Aid: EYES: FLUSH WITH WATER FOR AT LEAST 30 MINUTES. GET IMMEDIATE
MEDICAL ATTENTION. SKIN: FLUSH THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES.
REMOVE CONTAMINATED CLOTHING. SEE MD FOR IRRITATION. INHAL: REMOVE TO FRESH
AIR. GET MEDICAL ATTENTION. INGEST: GIVE WATER/MILK IF CONSCIOUS. DO NOT
INDUCE VOMITING. GET IMMEDIATE MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: WEAR APPROPRIATE PROTECTIVE CLOTHING. COLLECT INTO
CLOSED CONTAINERS. WASH SPILL AREA WITH WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS.
Handling And Storage Precautions: STORE IN A COOL AREA, AWAY FROM ACIDS AND
OTHER INCOMPATIBLE SUBSTANCES.
Other Precautions: PREVENT EYE & SKIN CONTACT. DO NOT BREATHE
MISTS/AEROSOLS. FOR SPRAY APPLICATION WHERE TLV/PEL MAY BE EXCEEDED,
NIOSH/MSHA APPROVED DUST/MIST RESPIRATOR (MASK) & APPROPRIATE EYE
PROTECTION IS RECOMMEN DED.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Extinguishing Media: THIS MATERIAL IS NOT COMBUSTIBLE. USE ANY MEDIA
APPROPRIATE FOR THE SURROUNDING FIRE.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N). COOL CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard: AT ELEVATED TEMPERATURES CONTAINERS MAY RUPTURE.
CONTENTS ARE CORROSIVE-ALL PERSONAL CONTACT SHOULD BE AVOIDED.
=======================================================
Control Measures
=======================================================
Respiratory Protection: FOR SPRAY APPLICATION WHERE THE TLV OR PEL MAY BE
EXCEEDED, NIOSH/MSHA APPROVED DUST/MIST RESPIRATOR (MASK) IS RECOMMENDED.
Ventilation: MECHANICAL IS GENERALLY ADEQUATE.
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
IMPERVIOUS APRON, BOOTS, ETC AS NEEDED.
Work Hygienic Practices: USE ONLY WITH APPROPRIATE PROTECTIVE EQUIPMENT. WASH
THOROUGHLY AFTER USE.
Supplemental Safety and Health: VP: SAME AS WATER @ 20C. EYE PROT: & FULL
LENGTH FACESHIELD (FP N).
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >212F,>100C
Vapor Pres: SUPDAT
Vapor Density: AS WATER
Spec Gravity: 1.33 (H*2O=1)
PH: 13
Evaporation Rate & Reference: SAME AS WATER
Solubility in Water: COMPLETE
Appearance and Odor: WHITE PASTE; NO ODOR.
Percent Volatiles by Volume: 51.5
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: ACIDS, FLAMMABLE LIQUIDS, ORGANIC HALOGENS, NITROMETHANE,
ALUMINUM.
Hazardous Decomposition Products: NONE KNOWN.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: PEEL AWAY I
Cage: 0ZTD8
Company Name: DUMOND CHEMICALS INC
Street: 1501 BROADWAY
Zipcode: 10036
Label Required IND: Y
Date Of Label Review: 04/09/1996
Status Code: C
Label Date: 04/09/1996
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: CORROSIVE. ACUTE: EYE: MAY CAUSE SEVERE BURNS -
POSSIBLE PERMANENT DAMAGE. SKIN: CHEMICAL BURNS WITH REDDENING AND PAIN,
DERMATITIS. INHALATION: EYE AND RESPIRATORY IRRITATION. INGESTION: BURNS TO
MOU TH, GASTROINTESTINAL CORROSION. CHRONIC: NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ISONATE 125M PURE MDI, 03008
CAGE:EO044
CAGE:96717
CAGE:EO044
============= Composition/Information on Ingredients =============
Ingred Name:ING 21: LOCAL LAWS & REGS.COMMONLY ACCEPTED METH FOR DISP
OF PLASTIC DRUMS ARE DISPOSAL IN APPRVD (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22: LANDFILL AFTER SHREDDING/INCINERATION IN APPRVD
INDUSTRIAL INCINERATOR/OTHER APPROP INCINERATOR (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: FACILITY.STEEL DRUMS ARE COMMONLY DISP IN APPRVD
LANDFILL AFTER CRUSHING/I/A/W OTHER APPRVD PROCS.
RTECS #:9999999ZZ
Ingred Name:ING 7: CARE.TREATMENT BASED ON JUDGMENT OF PHYSICIAN IN
RESPONSE TO RXNS OF PATIENT.THE MANIFESTATIONS (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: OF RESP SYMP,INCLUDING PULMONARY EDEMA,RESULTING
FROM ACUTE EXPOS MAY BE DELAYED. MAY CAUSE RESP SENSITIZATION.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:INVOLVED CALL CHEMTREC (800)424-9300.IF
TEMPORARY CONTROL OF ISOCYANATE VAP IS REQD A BLANKET (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: OF PROTEIN FOAM (AVAILABLE AT MOST FIRE
DEPARTMENTS)MAY BE PLACED OVER SPILL.LRG QTYS MAY BE (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: PUMPED INTO CLSD BUT NOT SEALED CNTNRS FOR
DISP.MINOR SPILL:ABSORB ISOCYANATE W/SAWDUST/OTHER (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: ABSORB & SHOVEL INTO OPEN TOP CNTNRS. DO NOT MAKE
PRESS TIGHT.TRANSPORT TO A WELL-VENT AREA (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: (OUTSIDE) & TREAT W/NEUTRALIZING SOLN CONSISTING OF
MIX OF H*2O & 3-8% CONC AMMONIUM HYDROXIDE (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: OR 5-10% SODIUM CARBONATE.ADD ABOUT 10 PARTS OF
NEUTRALIZER PER PART OF ISOCYANATE W/MIXING. (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: ALLOW TO STAND FOR 48 HOURS LETTING EVOLVED CARBON
DIOXIDE TO ESCAPE.CLEAN-UP:DECONTAMINATE (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: FLOOR USING H*2O/AMMONIA SOLN W/1-2% ADDED
DETERGENT LETTING STAND OVER AFFECTED AREA FOR AT (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:LEAST 10 MIN. COVER MOPS & BROOMS USED FOR THIS
W/PLASTIC & DISPOSE PROPERLY (OFTEN BY INCINERATION).
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: DRAINED, TRIPLE RINSED, & HOLED TO PVNT
REUSE. DISP (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: OF DRAIN & RINSE FLUID ACCORDING TO FED, STATE &
LOCAL LAWS & REGS.THE MOST COMMONLY ACCEPTED (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: METH IS IN AN APPRVD WASTEWATER TREATMENT
FACILITY.DRUMS SHOULD BE DISP OF I/A/W FED,STATE & (ING 22)
RTECS #:9999999ZZ
Ingred Name:DIPHENYLMETHANE DIISOCYANATE (CONTAINING INGREDIENT 2 AT
98%)
CAS:26447-40-5
Fraction by Wt: 100%
OSHA PEL:0.02 PPM
ACGIH TLV:0.02 PPM
Ingred Name:METHYLENE BISPHENYL ISOCYANATE; (4,4'
DIPHENYLMETHANEDIISOCYANATE) (MDI)
CAS:101-68-8
RTECS #:NQ9350000
Fraction by Wt: 98%
OSHA PEL:0.02 PPM, C
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SUPP DATA:THAT EXPOS TO MDI MAY CAUSE SIMILAR IMPAIRMENT OF
LUNG FUNCTION.SYSTEMIC & OTHER EFTS:BASED (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: ON AVAILABLE DATA, RPTD EXPOS ARE NOT ANTICIPATED TO
CAUSE ANY ADDNL SIGNIFICANT ADVERSE EFTS. (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: NUMEROUS IN VITRO (TEST TUBE) MUTAGENICITY STUDIES
HAVE BEEN DONE ON MDI.POS RESULTS HAVE BEEN (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: RPTD IN FEW STUDIES; HOWEVER, MAJORITY HAVE BEEN
NEGATIVE.RESULTS OF MUTAGENICITY STUDY IN ANIMALS WERE NEGATIVE.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:DIFFICULT, GIVE OXYGEN.CALL A PHYSICIAN.NOTE
TO PHYSICIAN:NO SPECIFIC ANTIDOTE.SUPPORTIVE (ING 8)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:ORAL(RAT): >15,000 MG/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:MAY CAUSE SLIGHT EYE
IRRITATION.CORNEAL INJ IS UNLIKELY.SKIN:MAY CAUSE ALLERGIC SKIN RXN
IN SUSCEPTIBLE INDIVIDUALS.PRLNGD/RPTD EXPOS MAY CAUSE SKIN
IRRIT.MAY STAIN SKIN.SKIN ABSORB:SINGLE DOSE PR LNGD EXPOS IS NOT
LIKELY TO RSLT IN MATL BEING ABSORBED THROUGH SKIN IN HARMFUL
AMOUNTS.INGEST: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SINGLE DOSE ORAL TOXICITY IS LOW.NO
HAZ ANTICIPATED FROM INGEST INCIDENTAL TO INDUSTRIAL
EXPOS.INHAL:MAY CAUSE RESP SENSITIZATION IN SUSCEPTIBLE
INDIVIDUALS. AT ROOM TEMP,VAPS ARE MINIMAL DUE TO LOW VAP PRESS.IF
HEATED/SPRAYED AS AEROSOL,EXCESSIVE CONC ARE ATTAINABLE THAT COULD
BE HAZ ON SINGLE (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IRRIGATE W/FLOWING H*2O IMMED & CONTINUOUSLY FOR AT
LEAST 15 MIN.CONSULT MED PERS.DUE TO HIGH VISCOSITY, MATL MAY BE
DFCLT TO REMOVE FROM EYES.SKIN:WASH OFF IN FLOWING
H*2O/SHOWER.INGEST:NO ADVER SE EFTS ANTICIPATED BY THIS ROUTE OF
EXPOS INCIDENTAL TO PROPER INDUSTRIAL HNDLG.CALL MD IMMED
.INHAL:REMOVE TO FRESH AIR.IF NOT BRTHG,GIVE MOUTH-TO-MOUTH
RESUSCITATION.IF BRTHG IS (ING 7)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>350F,>177C
Extinguishing Media:CO*2,DRY CHEM/FOAM.IF H*20 IS USED,IT SHOULD BE IN
VERY LRG QTY.THE RXN BETWEEN H*2O & HOT ISOCYANATE MAY BE VIGOROUS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DOWN-WIND PERSONNEL MUST BE EVACUATED.DO
NOT RESEAL CONTAMINATED CONTAINERS SINCE PRESSURE BUILD-UP MAY
CAUSE RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AND VENTILATE SPILL AREA, DIKE SPILL
TO PVNT ENTRY INTO WATER SYSTEM, WEAR FULL PROT EQUIP INCLUDING
NIOSH/MSHA APPRVD RESP EQUIP DURING CLEAN UP.MAJOR SPILL:CALL DOW
CHEMICAL U.S.A. (409)238 -2112.IF TRANSPORTATION SPILL (ING 10)
Neutralizing Agent:MIXTURE OF WATER AND 3-8% CONC AMMONIUM HYDROXIDE OR
5-10% SODIUM CARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT FROM MOISTURE
CONTAMINATION(EXOTHERMIC GENERATION OF CO*2 MAY CAUSE DANGEROUS
PRESSURE.)
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ATMOSPHERIC LEVS SHOULD BE MAINTAINED BELOW
EXPOS GUIDELINE.WHEN RESP PROT IS REQD FOR CERTAIN OPER,USE
NIOSH/MSHA APPRVD SUPP-AIR RESP.FOR EMERGENCY/OTHER CNDTNS WHERE
EXPOS GUIDELINE GREATLY EXCEEDE D, USE NIOSH/MSHA APPRVD POS PRESS
SCBA.
Ventilation:PROVIDE GEN &/OR LOCAL EXHAUST VENT TO CONTROL AIRBORNE
LEVELS BELOW EXPOSURE GUIDELINES.
Other Protective Equipment:BOOTS,APRON,OR FULL-BODY SUIT WILL DEPEND ON
OPERATION.
Work Hygienic Practices:REMOVE CONTAM CLOTHING IMMEDIATELY, WASH SKIN
AREA W/SOAP AND WATER, AND LAUNDER CLOTHING BEFORE REUSE.
Supplemental Safety and Health
VP:3X10 (-4) @ 43C. MATL TO AVOID:INSOLUBLE UREA.COMBINED EFT OF CO*2 &
HEAT CAN PRDCE ENOUGH PRESS TO RUPTURE CLSD CNTNR.EFTS OF
OVEREXP:EXPOS.EXCESS EXPOS MAY CAUSE IRRIT OF EYES,UPPER RESP
TRACT,& LUNGS.EFTS MAY BE DELAYED.DECREASED VENT CAPACITY HAS BEEN
ASSOC W/EXPOS TO SIMILAR ISOCYANATES;IT IS POSS (ING 3)
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:392F,200C
Decomp Temp:Decomp Text:500F, 260C
Vapor Pres:SUPP DATA
Vapor Density:8.6
Spec Gravity:1.23 @110 F
Solubility in Water:REACTS
Appearance and Odor:WHITE TO YELLOW SOLID AT ROOM TEMPERATURE; LIQUID
ABOVE 100 F, PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
H*2O,ACID,BASE,ALCOHOLS,METAL COMPOUNDS,SURF ACTIVE MATLS.AVOID H*2O AS
IT REACTS TO FORM HEAT,CO*2 & (SUPP DATA)
Stability Condition to Avoid:STORE AS SOLID AT -20 F TO +10 F; AS
LIQUID 105-115 F.
Hazardous Decomposition Products:ISOCYANATE VAPOR AND MIST, CARBON
DIOXIDE, CARBON MONOXIDE, NITROGEN OXIDES & TRACES OF HYDROGEN
CYANIDE.
Conditions to Avoid Polymerization:MAY OCCUR WITH INCOMPATIBLE
REACTANTS, ESPECIALLY STRONG BASES, WATER OR TEMPERATURES OVER 175
C.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW ALL FED,STATE & LOCAL REGS. LIQS ARE
USUALLY INCINERATED IN A PROPER FACILITY.SOLIDS ARE USUALLY
INCINERATED/LANDFILLED.EMPTY DRUMS SHOULD BE FILLED W/H*2O.LET DRUM
STAND UNSEALED FOR 48 HOURS. BEFORE DISP DRUMS SHOULD BE (ING 19)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DUBL-CHEK PENETRANTS RC50
CAGE:21405
CAGE:37676
CAGE:21405
============= Composition/Information on Ingredients =============
Ingred Name:MIXTURE ESTERS, PHOSPHATE/PHTHALATE ( CAS NOS. 27961-21-5
AND 68515-49-1)
Other REC Limits:5MG/M3
Ingred Name:HYDROTREATED MIDDLE PETROLEUM DISTILLATE
CAS:64742-46-7
RTECS #:JN9379645
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5MG/M3
ACGIH TLV:5MG/M3
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE, SKIN, RESPIRATORY TRACT
IRRITATION. INHALATION MAY CAUSE LIGHT HEADEDNESS.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE, SKIN, GASTROINTESTINAL & RESPIRATORY TRACT
IRRITATION SUCH AS TEARING, RASH, NAUSEA OR DIFFICULTY IN
BREATHING.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, STOMACH OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE HOLDING
EYELID. GET MEDICAL ATTENTION IMMEDIATELY. SKIN: WASH WITH SOAP &
WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL ADVICE.
INHALATION: REMOV E TO FRESH AIR. GIVE MOUTH-TO-MOUTH RESUSCITATION
IF NOT BREATHING. GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET MEDICAL
ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:200F,93C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: WIPE/SOAK UP WITH PAPER TOWEL OR
INERT ABSORBENT. PUT IN DISPOSAL CONTAINER. LARGE SPILL: ELIMINATE
SOURCES OF IGNITION, EVACUATE AND VENTILATE AREA. DIKE TO RETAIN
RUN OFF. VACUUM UP OR PUMP FREE LIQUID INTO DOT SALVAGE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.DO NOT CUT OR WELD
Other Precautions:DO NOT INGEST. USE WITH ADEQUATE VENTILATION. DO NOT
BREATHE VAPOR OR MIST. DO NOT GET IN EYES. WASH THOROUGHLY AFTER
HANDLING AND BEFORE EATING, DRINKING OR SMOKING. AVOID REPEATED OR
PROLONGED CONTA CT WITH SKIN OR EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED RESPIRATOR IF
VENTILATION DOES NOT MAINTAIN INHALATION EXPOSURES BELOW PEL/TLV.
WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR HIGH LEVELS
OF CONTAMINATES.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS REQUIRED. LOCAL EXHAUST
RECOMMENDED FOR USE IN ENCLOSED AREAS.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES.
LAUNDER CONTAMINATED CLOTHING BEFORE WEARING. WASH BEFORE EATING.
DO NOT SMOKE.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS. DO NOT INGEST. READ PRECAUTIONS ON
LABEL BEFORE USE.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:440F,227C
Spec Gravity:0.90
Solubility in Water:SLIGHTLY MISCIBLE
Appearance and Odor:YELLOW, GREEN LIQUID, PETROLEUM ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE AND UNIDENTIFIED
ORGANIC COMPOUNDS UPON COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: 706 DYNA-PRO RUBBERIZED UNDERCOATING & SOUND DEADENER
Cage: 16522
Proprietary Ind: Y
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 16522
=======================================================
Contractor Summary
=======================================================
Cage: 16522
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: EYES: SEVERE IRRITATION, REDNESS, TEARING, BLURRED VISION.
SKIN: IRRITATION, DEFATTING, DERMATITIS. INHALATION: NASAL/RESPIRATORY
IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, HEADACHE, UNCONSCIOUSNESS/AS
PHYXIATION. INGESTION: NAUSEA, HARMFUL OR FATAL.
Explanation Of Carcinogenicity: STYRENE IS A CONSIDERED TO BE 2B HUMAN
CARCINOGEN.
Signs And Symptions Of Overexposure: INHALATION: REPEATED/PROLONGED
OVEREXPOSURE TO SOLVENTS CAUSES PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
EYES: SEVERE IRRITATION, REDNESS, TEARING, BLURRED VISION. SKIN: IRRITATION,
DEFATTING, DERMATIT IS. INGESTION: ASPIRATION OF MATERIAL INTO THE LUNGS DUE
TO VOMITING CAUSES CHEMICAL PNEUMONITIS, FATAL & NAUSEA.
Medical Cond Aggravated By Exposure: EYE, SKIN & RESPIRATORY DISORDERS
First Aid: EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH THOROUGHLY EXPOSED W/SOAP & WATER. INHALATION: IF AFFECTD, REMOVE
INDIVIDUAL TO FRESH AIR. IF BREATHING IS DIFFICULT, ADMINISTER O XYGEN. IF
BREATHING HAD STOPPED, GIVE ARTIFICIAL RESPIRATION. KEEP PERSON WARM &
QUIET. INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: KEEP ALL UNPROTECTED PEOPLE AWAY. REMOVE ALL SOURCES
OF IGNITION. CLEAN W/INERT ABSORBENT.
Waste Disposal Methods: DISPOSE IN ACCORDANCE W/FEDERAL, STATE, & LOCAL
REGULATIONS.
Handling And Storage Precautions: AVOID BREATHING VAPORS. DON'T WELD OR CUT
NEAR SURFACE FOR SEVERAL HOURS AFTER APPLICATION. AVOID STATIC CHARGES.
EXTREMELY FLAMMABLE.
Other Precautions: USE ONLY IN WELL VENTILATED AREAS W/ENOUGH AIR MOVEMENT TO
REMOVE VAPORS. AEROSOL CONTAINERS LEFT IN CAR TRUNK OR HOT CAR INTERIROR MAY
BURST. AVOID INHALATION OF VAPORS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: FOAM, CO2 OR DRY CHEMICAL
Fire Fighting Procedures: KEEP CONTAINERS COOL, USE EQUIPMENT TO PROTECT
AGAINST BURST
Unusual Fire/Explosion Hazard: SOLVENT VAPORS EMITTED BY THIS PRODUCT DURING
SPRAYING & ALSO FROM THE FRESHLY COATED SURFACE WILL BURN, MAY IGNITE
EXPLOSIVELY & FLASHBACK. FLAMMABLE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE MSHA/NIOSH APPROVED RESPIRATOR FOR ORGANIC
SOLVENT VAPORS & MIST IF TLV'S ARE EXCEEDED.
Ventilation: LOCAL EXHAUST: EXPLOSION PROOF. MECHANICAL (GENERAL): RECOMMENDED
Work Hygienic Practices: REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Density: >AIR
Solubility in Water: NEGLIGIBLE
Appearance and Odor: BLACK - SOLVENT ODOR.
Percent Volatiles by Volume: <50%
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, SPARKS, OPEN FLAMES, SOURCES OF IGNITION
Materials To Avoid: STRONG OXIDIZING AGENTS
Hazardous Decomposition Products: CO, CO2, VARIOUS HYDCARBONS
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 706 DYNA-PRO RUBBERIZED UNDERCOATING & SOUND DEADENER
Cage: 16522
Company Name: BONDO/MAR-HYDE CORP
Street: 3700 ATLANTA INDUSTRIAL PKWY NW
Zipcode: 30331
Label Required IND: Y
Date Of Label Review: 05/05/1992
Status Code: C
Label Date: 05/05/1992
Origination Code: F
Skin Protection IND: YES
Signal Word: DANGER
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: EYES: SEVERE IRRITATION, REDNESS, TEARING, BLURRED
VISION. SKIN: IRRITATION, DEFATTING, DERMATITIS. INHALATION:
NASAL/RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, HEADACHE,
UNCONSCIOUSNESS/AS PHYXIATION. INGESTION: NAUSEA, HARMFUL OR FATAL.
CARCINOGEN. TARGET ORGANS: BRAIN, NERVOUS SYSTEM DAMAGE.
TARGET ORGANS: BRAIN & NERVOUS SYSTEM.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MASTERMET, 40-6370-064
CAGE:09410
CAGE:09410
============= Composition/Information on Ingredients =============
Ingred Name:SILICA; (AMORPHOUS)
CAS:7631-86-9
Fraction by Wt: 40-70%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: PROLONGED INHALATION OF
DUST(DRIED SOLUTION), IF GENERATED, MAY CAUSE PNEUMONOCONIOSIS.
EYE/SKIN: CAN CAUSE TRANSIENT IRRITATION. INHAL: MAY CAUSE IRRIT TO
RESP TRACT & LUNGS IF DUST IS INHALED .
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALH HAZARDS.
Medical Cond Aggravated by Exposure:PRLNGD BRTHG OF DRIED SOLUTION CAN
INCREASE LUNG INJURY IN INDIVIDUALS W/EMPHYSEMA, ASTHMA/OTHER LUNG
DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CALL A PHYS.
SKIN: FLUSH W/WATER FOR 15 MINUTES. INGEST: DO NOT INDUCE VOMIT.
GIVE WATER. CALL A PHYS. INHAL: REMOVE TO FRESH AIR. TREAT
SYMPTOMS-CALL A PHYSICIAN. NO SPEC ANTIDOTE IS KNOWN. IF UNCON,
HAVE TROUBLE BREATHING OR CONVULS, DO NOT GIVE WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN WITH ABSORBENT MATERIAL. SHOVEL
RECLAIMED LIQUID AND ABSORBENT INTO RECOVERY OR SALVAGE DRUMS FOR
DISPOSAL. 40 CFR 117, 302 NOTIFICATION OF SPILLS OF PRODUCT IS NOT
REQUIRED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT TEMPERATURES BETWEEN 40-120F.
PROTECT FROM FREEZING.
Other Precautions:NONE KNOWN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION NOT NORMALLY REQUIRED. IF
SIGNIFICANT VAPORS/MISTS ARE GENERATED WEAR A NIOSH/MSHA APPROVED
RESPIRATOR.
Ventilation:LOCAL EXHAUST. MECH(GEN): GENERAL VENTILATION IS
RECOMMENDED.
Other Protective Equipment:LAUNDER CONTAMD CLTHG BEFORE REUSE.
Work Hygienic Practices:GOOD PERSONAL HYGIENE TO BE FOLLOWED AT ALL
TIMES.
Supplemental Safety and Health
SPEC GRAV: 1.38-1.40(H*2O=1). PH: 9.8-10.2(NEAT). HAZ DECOMP: HEAT,
SPLATTERING OR BOILING AND RELEASE OF TOXIC FUMES.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:100F,38C
Spec Gravity:SUPP DATA
pH:SUPDAT
Solubility in Water:COMPLETELY
Appearance and Odor:BLUE LIQUID-NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH ALUMINUM.
Hazardous Decomposition Products:AVOID CONT W/STRONG ACIDS (EG
SULFURIC, PHOSPHORIC, NITRIC, HYDROCHLORIC, CHROMIC, SULFONIC)
WHICH CAN GENERATE(SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE DOES NOT MEET CRITERIA OF A HAZ WASTE AS
DEFINED UNDER (RCRA) 40CFR261. AS A NON-HAZ LIQ WASTE IT SHOULD BE
SOLIDIFIED W/STABLIZING AGENTS SO THAT NO FRE LIQ REMAINS BEORE
DISP TO AN INDUST WAST E LANDFILL. DISPOSE OF I/A/W LOC, ST & FED
REGS.
| 1 | gloves_mandatory |
=======================================================
Product ID: HYDRANAL COMPOSITE 1-34827
Cage: 0RIR4
Box: 1026
=======================================================
Contractor Summary
=======================================================
Cage: 0R1R4
Cage: 0RIR4
Box: 1026
=======================================================
Ingredients
=======================================================
Cas: 111-77-3
RTECS #: KL6125000
% Wt: >70
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 288-32-4
RTECS #: NI3325000
% Wt: 10-15
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 7446-09-5
RTECS #: WS4550000
% Wt: <10
OSHA PEL: 5 PPM
ACGIH TLV: 2 PPM/5 STEL
------------------------------
Cas: 7553-56-2
RTECS #: NN1575000
% Wt: <5
OSHA PEL: C 0.1 PPM
ACGIH TLV: C 0.1 PPM
------------------------------
Cas: 10034-85-2
RTECS #: MW3760000
% Wt: 1
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
NORMAL USE. CNTN HYDRIODIC ACID WHICH
-----------------------------
DIOXIDE IS AN IN-VITRO MUTAGEN. INHAL STUDIES
-----------------------------
THERE ARE 2 TSCA SECTION 8(3) RPTS ON
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:PROD CNTNS SULFUR DIOXIDE WHICH IS SEV IRRITANT TO
EYES, MUC MEMB, & SKIN. IT AFFECTS UPPER RESP TRACT & BRONCHI; CAN
ALSO CAUSE RESP PARALYSIS & PULM EDEMA, SENSITIVE PERSONS, PARTICULARY
ASTHM ATICS, MAY EXPERIENCE RESP ALLERGIC RXN. HIGH CONC OF SULFUR DIOXIDE
CAN BE FATAL. PROD CNTN IODINE (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:WHICH IS SKIN, EYE, MUC MEMB,
& RESP SYS IRRITANT. CHRONIC ABSORP OF IODINE CAUSES "IODISM", CHARACT BY
INSOMNIA CONJUNC, RUNNY NOSE, BRONCH, TREMOR, TACHYCARDIA, PAROTITIS, DIARR,
& WEIGHT L OSS. IODINE HAS POOR WARNING PROPERTIES, AS TLV/PEL IS 0.1 PPM
CEILING, BUT HUMAN SUBJECT TOLERATED 0.57 PPM FOR(SUPDAT)
Medical Cond Aggravated By Exposure: SKIN & EYE CONDITIONS, LIVER &
KIDNEY CNDTNS, RESP CNDTNS. PERSONS WITH ASTHMA HAVE SHOWN A GREATER
SENSITIVITY TO SULFUR DIOXIDE.
First Aid: INHAL:CONSULT PHYS IF IRRIT TO RESP PASSAGES OCCURS. EYE:HOLD EYES
OPEN & FLUSH FOR @ LEAST 15 MINS W/LG QTYS OF WATER. SEEK MED ATTN.
SKIN:REMOVE CONTAMD CLTHG. FLUSH AFFECTED AREA W/PLENTY OF WATER. SEEK MED
ATTN. INGEST:IF PERSON IS CONSCIOUS, GIVE WATER/MILK TO DILUTE STOMACH
CONTENTS.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: WEARING APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT,
CONTAIN SPILL, COLLECT INTO SUITABLE CONTAINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
Handling And Storage Precautions: THIS PROD IS AN ANALYTICAL REAGENT & IS
COVERED BY TSCA R&D EXEMPTION.
Other Precautions: IT IS PROVIDED FOR USE AS AN ANALYTICAL REAGENT & NOT
FOR INCORPORATION INTO COMMERCIAL PROD & MUST BE USED UNDER SUPERVISION
OF A TECHNICALLY QUALIFIED INDIVIDUAL.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 163F,73C
Extinguishing Media: CARBON DIOXIDE, WATER SPRAY, FOAM OR DRY CHEMICAL.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: EMITS TOXIC AND CORROSIVE FUMES UNDER FIRE
CONDITIONS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF AIRBORNE CONC POSE A HLTH HAZ, BECOME IRRIT, OR
EXCEED REC LIM, USE A NIOSH/MSHA APPRVD RESP I/A/W OSHA RESP PROT
REQUIREMENTS UNDER 29 CFR 1910.134.
Ventilation: USE LOC EXHAUST VENT/RESP PROT TO MAINTAIN EMPLOYEE EXPOS BELOW
THE PEL/TLV.
Other Protective Equipment: ANSI APPRVD EMERGENCY EYE WASH & DELUGE SHOWER (FP
N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: EFTS OF OVEREXP:5 MINS IN 1 TEST W/OUT EYE
IRRIT. HYPERSENS TO IODINE SHOWN BY SKIN RASH HAS BEEN RPTD. DIETHYLENE
GLYCOL MONOMETHYL ETHER (METHYL CARBITOL) IS RPTD TO BE LOW IN ORAL TOX, ONLY
SLIGHTL Y IRRIT IN TRANSIENT FASHION TO EYES ONCONT; IT MAY BE ABSORBED THRU
SKIN, HOWEVER, IT IS NOT SKIN IRRITANT. IT
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Density: 1.12 @ 20C
PH: 4-5
Evaporation Rate & Reference: NOT KNOWN
Solubility in Water: MISCIBLE
Appearance and Odor: BROWN LIQUID WITH A WEAK CHARACTERISTIC ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: IGNITION SOURCES.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: THERM DECOMP MAY GENERATE CARBON DIOXIDE,
CARBON MONOXIDE & OXIDES OF NITROGEN & SULFUR & COMPOUNDS OF IODINE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: HYDRANAL COMPOSITE 1-34827
Cage: 0RIR4
Company Name: HOECHST CELANESE CORP
Street: UNKNOWN
PO Box: 1026
Zipcode: 28201-1026
Label Required IND: Y
Date Of Label Review: 01/11/1996
Status Code: C
Label Date: 01/11/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:SEVERE EYE, SKIN AND MUCOUS
MEMBRANES, AND RESPIRATORY IRRITANT. CAN CAUSE RESPIRATORY PARALYSIS,
PULMONARY EDEMA, ASTHMATIC AND ALLERGIC REACTIONS. CAN BE FATAL. CHRONIC:MAY
CAUSE IODISM, INSOMNIA, CONJUNCTIVITIS, RUNNYNOSE, BRONCHITIS, AND TREMOR,
TACHYCARDIA, PAROTITIS, DIARRHEA AND WEIGHT LOSS. POSSIBLE MUTAGEN
W/REPRODUCTIVE EFFECTS.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SOLDER FLUX PASTE, 6-411
CAGE:ESPSO
CAGE:ESPSO
============= Composition/Information on Ingredients =============
Ingred Name:ROSIN ACID; (ROSIN)
CAS:8050-09-7
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALPHA-TERPINEOL; (TERPENE)
CAS:98-55-5
RTECS #:WZ6700000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACTIVATORS; (ACTIVATOR MIXTURE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ORGANIC THIXATROPE MIXTURE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OTHER INGREDIENTS
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: ASPIRATION MAY CAUSE LUNG
INJURY. INGESTION MAY CAUSE DAMAGE. CHRONIC: MAY CAUSE SKIN OR EYE
IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SKIN/EYE IRRITATION, NAUSEA, HEADACHE.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:SEEK MEDICAL ASSISTANCE FOR FURTHER TREATMENT, OBSERVATION
AND SUPPORT IF NECESSARY. EYE: REMOVE CONTACT LENSES IMMEDIATELY.
FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES. SEEK MED ATTN.
SKIN: WASHTHORO W/SOAP & WATER. IF IRRIT PERSISTS, CONSULT A
PHYS. INHAL: REMOVE TO FRESH AIR. INGEST: DO NOT INDUCE VOMITING.
SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:210F,99C
Extinguishing Media:DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:FLUX MAY BURN IF CONTACTED WITH FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:PUT INTO PROPERLY LABELED WASTE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORAGE NEAR HEAT/FLAME.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MAINTAIN ADEQUATE EXHAUST. USE NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST. OTHER: OPERATION SHOULD BE PROTECTED FROM
FUMES.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:MAINTAIN GOOD INDUSTRIAL HYGIENE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:388F,198C
Melt/Freeze Pt:M.P/F.P Text:122F,50C
Spec Gravity:<1(H*2O=1)
Solubility in Water:0
Appearance and Odor:AMBER GEL, MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LACQUER C/N GLOSS CLEAR ID 786800
Preparer's Name:W A ELLISON
CAGE:61196
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SOLVENT)(SARA III) (VAPOR PRESSURE 22 MM HG @
20C) (LFL 1.7; UFL 7.1)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOBUTYL ALCOHOL (SARA III) (SOLVENT) (LFL 1.0; UFL 11.0)
(VAPOR PRESSURE 10 MM HG @ 20C)
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VM&P NAPHTHA (VAPOR PRESSURE 40 MM HG @ 20C) (LFL:1.0 UFL:
6.0)
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:300 PPM;STEL 400 PPM
ACGIH TLV:300 PPM; 1350 MG/M3
Ingred Name:ISOPROPYL ALCOHOL (SARA III) (SOLVENT) (LFL 3.0; LFL 13.0)
(VAPOR PRESSURE 33 MM HG @ 20C)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM/STEL 500 PPM
ACGIH TLV:400 PPM/STEL 500 PPM
Ingred Name:NITROCELLULOSE (RESIN)
CAS:9004-70-0
RTECS #:QW9700000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
Ingred Name:DI(2-ETHYLHEXYL)PHTHALATE (ADDITIVE) (SARA III)
CAS:117-81-7
RTECS #:TI0350000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ISOBUTYL ACETATE (SARA III) (SOLVENT) (LFL 2.0; UFL 11.0)
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 25%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM; 700 MG/M3
ACGIH TLV:150 PPM; 700 MG/M3
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:N-HEPTANE (SOLVENT) (LFL 1.0; UFL 7.0) (VAPOR PRESSURE 40
MM HG @ 20C)
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9293
Ingred Name:HEXANE (SOLVENT) (LFL 1.0; UFL 8.0) (VAPOR PRESSURE 120 MM
HG @ 20C)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:VOC: 635 G/L LESS WATER; CALCULATED
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE; INGEST: GI IRRIT, NAUSEA,
VOMITING. ASPIRATION INTO LUNG MAY CAUSE CHEMICAL PNEUMONITIS (CAN
BE FATAL). INHAL: NOSE/THROAT IRRIT. ACUTE CENTRAL NERVOUS SYSTEM
DEPRESSION (HEADACHES, DIZZINESS, NAUSEA, CONFUSION). EYE:
IRRITATION. SKIN: DEFATTING, IRRITATION.
Explanation of Carcinogenicity:SUFFICIENT EVIDENCE OF CARCINOGENICITY
OF DI(2-ETHYLHEXY)PHTHALATE (DEHP) IN ANIMALS.
Effects of Overexposure:CHRONIC; LIVER DAMAGE, PERIPHERAL NERVOUS
SYSTEM DAMAGE, ENHANCE NEUROTOXICITY (SYNERGISTIC EFFECT IN
PERIPHERAL NEUROPATHY). REPORTS HAVE ASSOCIATED PROLONGED REPEATED
OCCUPATIONAL OVEREXPOSURE TO SO LVENTS WITH PERMANENT BRAIN AND
NERVOUSSYSTEM DAMAGE. CONCENTRATING & INHALING PRODUCT MAY BE
HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. GET MEDICAL ATTENTION. SKIN: WASH AFFECTED AREA
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION.EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. GET
IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:-9F,-23C
Autoignition Temp:Autoignition Temp Text:300 C
Lower Limits:1.0 %
Upper Limits:13.0 %
Extinguishing Media:NFPA CLASS B FIRE EXTINGUISHERS (CO2, DRY CHEM,
ALCOHOL FOAM) FOR FLAMMABLE LIQ. POLYMER FOAM PREFERRED FOR LARGE
FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE TO COOL EXPOSED
CONTAINER TO PREVENT PRESSURE BUILDUP/AUTO-IGNITION/EXPLOSION W/
EXTREME HEAT. IF WATER USED, FOG NOZZLES PREFERRE
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY CAUSE HEALTH HAZARD. SYMPTOMS MAY NOT
BE IMMEDIATELY APPARENT. GET MEDICAL ATTENTION.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILLAGE. ELIMINATE SOURCES OF
IGNITION. STOP LEAK AT SOURCE IF SAFE. VENTILATE AREA. EVACUATE
NONESSENTIAL PERSONNEL. PUMP LIQUID INTO DOT DISPOSAL DRUM. ABSORB
REMAINING LIQUID ONTO INERT AB SORBENT & PLACE IN DOT DISPOSAL
DRUM. WASH AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 115 F. STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29 CFR 1910.106. DONT INGEST.
CLOSE CONTAINER AFTER EACH USE.
Other Precautions:KEEP FROM CHILDREN. DONT BREATH SANDING DUST. EMPTY
CONTAINERS MUST NOT BE WASHED & REUSED. GROUND & BOND CONTAINERS TO
RECEIVING CONTAINER. DONT WELD/BRAZE/CUT ON EMPTY CNTNR. NEVER USE
PRESSURE TO E MPTY. DRUM IS NOT A PRESSURE VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS PER
CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND NIOSH RESPIRATOR
SELECTION.
Ventilation:LOCAL EXHAUST VENT TO KEEP BELOW NUISANCE DUST LIMITS &
PEL. REFER TO "INDUST VENT-MANUAL FOR RECOMM PRACTICES" ACGIH.
Other Protective Equipment:EYEWASH FACILITY, SAFETY SHOWER.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:156 TO 302F
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Decomp Temp:Decomp Text:1832F,1000C
Vapor Pres:120 @ 68F
Vapor Density:> AIR
Spec Gravity:0.9
pH:4-7STD
Viscosity:> 200 CST
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:78 %
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F) AND SOURCES
OF IGNITION.
Hazardous Decomposition Products:SMOKE, CO, CO2. OXIDES OF NITROGEN MAY
BE GENERATED.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PISTON INSULATOR(5003968)
CAGE:EO533
CAGE:EO533
CAGE:25500
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS(CHRYSOTILE), CAS. #12001-29-5; WT %: 50-80%.
RTECS #:GC2625000
Fraction by Wt: 65%.
ACGIH TLV:2.0 FB/CC
Ingred Name:PHENOL-FORMALDEHYDE RESIN, CAS.# 9003-35-4, WT %: 20-40%.
Fraction by Wt: 30%.
Ingred Name:ZINC STEARATE
CAS:557-05-1
RTECS #:ZH5200000
Fraction by Wt: 17.5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Effects of Overexposure:INHAL: (DUST)- ACUTE:NO EFFECTS EXPECTED;
CHRONIC: MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; EYES: FLOW
W/H*2O. IF IRRITATION OCCURS, GET MED. ATTN.; SKIN: WASH W/SOAP &
WATER; INGEST: GET MED. ATTN. OTHER: CHANGE CLOTHING,IF
NECESSARY,TO AVO ID CARRYING DUST PARTICLES TO OTHER ENVIRONS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:COMBUSTION PRODUCTS MAY BE TOXIC. USE SCBA IN
FIRE FIGHTING
Unusual Fire/Explosion Hazard:MFR CITES NONE
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM OR WET CLEAN IF DUST IS INVOLVED. ANY
VACUUM SYSTEM SHOULD BE EQUIPPED W/AN OUTLET "HEPA" FILTER TO
PREVENT REINTRODUCING ASBESTOS FIBERS TO THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE TO MINIMIZE DUST FORMATION OR
RETENTION. AVOID INHALATION OF DUSTS & VAPORS.
Other Precautions:CHRYSOTILE ASBESTOS IS LOCKED-IN APHENOLIC RESIN. AS
MADE, THE LOCKED-IN ASBESTOS DOES NOT PRESENT A HAZARD. ONLY WHEN
RESIN SYSTEM IS ABRADED & DUST GENERATED, ASBESTOS FIBER MAYBE
RELEASED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD RESP. FOR ASBESTOS IF EXPOSURE
> ESTABLISHED LIMIT
Ventilation:LOCAL EXHAUST IF HI-CONC. OF DUST GENERATED BY
MECH.ABRASION
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
MSDS DATE:1/87
================== Physical/Chemical Properties ==================
HCC:T6
Appearance and Odor:REDDISH BROWN MATERIAL(BRAKE COMPONENT)
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:OXIDES OF CARBON, PHENOL, FORMALDEHYE
FUMES
Conditions to Avoid Polymerization:WILL NOT POLYMERIZE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT IAW 40 CFR 61 SUBPART M. USE LANDFILLS APPROVED FOR
ASBESTOS DISPOSAL. SCRAP PARTS ARE NOT FRIABLE & ARE NOT RESTRICTED
UNDER AIR POLLUTION REGULATI ONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SCOTCHCAST ELECTRICAL INSULATING RESIN (POLYOL)
Kit Part:Y
CAGE:75037
CAGE:75037
============= Composition/Information on Ingredients =============
Ingred Name:ZEOLITES
CAS:1318-02-1
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CASTOR OIL
CAS:8001-79-4
RTECS #:FI4100000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROXY TERMINATED 1,3BUTADIENE HOMOPOLYMER
CAS:69102-90-5
Fraction by Wt: 35-40%
Other REC Limits:NONE RECOMMENDED
Ingred Name:N,N BIS-(2-HYDROXYPROPYL)-ANILINE
CAS:3077-13-2
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIPROPYLENE GLYCOL
CAS:110-98-5
RTECS #:UB8785000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION MAY CAUSE IRRITATION
OF UPPER RESPIRATORY TRACT. CONTACT MAY CAUSE SKIN OR EYE
IRRITATION. SWALLOWING IS AN UNLIKELY ROUTE OF EXPOSURE. CHRONIC:
PROLONGED OR REPEATED EXPOSURE MAY CA USE AN ALLERGIC RESPIRATORY
REACTION.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED: SORE THROAT & NOSE, COUGHING,
SNEEZING. EYES: REDNESS, SWELLING, PAIN, TEARING. SKIN: REDNESS,
SWELLING, ITCHING. ALLERGIC RESPIRATORY REACTION: DIFFICULTY
BREATHING, WHEEZING, TIGHTNESS IN C HEST, RESPIRATORY FAILURE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALED: REMOVE TO FRESH AIR. IF SYMPTOMS/SIGNS CONTINUE,
CALL A DOCTOR. SWALLOWED: DO NOT INDUCE VOMITING! IF CONSCIOUS,
DRINK 1-2 GLASSES OF WATER. GET IMMEDIATE MEDICAL ATTENTION. EYES:
FLUSH WITHLOTS OF WATER FOR 15 MINUTES, HOLD LIDSOPEN. GET
MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHES. WASH WITH
SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>320F,>160C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:COMBUSTION MAY FORM TOXIC GASES/FUMES
SUCH AS OXIDES OF CARBON, OXIDES OF NITROGEN, HYDROGEN CYANIDE,
ISOCYANATES, OTHER TOXIC VAPORS/PARTICULATES, GASES, ETC.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROPER PROTECTIVE EQUIPMENT.POUR
DECONTAMINANT SOLUTION ON SPILL,ALLOW TO REACT FOR 10
MINUTES.ALTERNATIVLEY POUR WATER ON SPILL,LET REACT 30
MINUTES.COVER W/ABSORBENT,PLACE IN APPROVED DRUM. DO NOT SEAL DRUM
FOR 48 HOURS. NEUTRALIZE SPILL SITE.
Neutralizing Agent:DECONTAMINANT SOLUTION- 80% WATER, 8% CONCENTRATED
AMMONIA, 2% DETERGENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER IN A WELL-VENTIALTED
AREA AWAY FROM INCOMPATIBLE MATERIALS. KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED. DO NOT HEAT UNDER
CONFINEMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR EMERGENCY OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR WITH
ORGANIC VAPOR CARTRIDGE, OR SUPPLIED AIR RESPIRATOR OR SCBA, AS
REQUIRED. USE IAW 29 CFR 19 10.134.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION TO MAINTAIN EXPOSURE
BELOW REGULATORY LIMITS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
THIS ITEM IS PART B OF A 3 PART KIT. OTHER PARTS ARE UNDER
5970-00-D00-3180 PART A (PREPOLYMER) AND 5975-00-D003179, CC-2 PREP
KIT/CABLE CLEANER. ALL PARTS ARE PART OF 3M KIT NUMBER-5903,
CATALOGUE NU MBER 80-7110-7800-8, PORCELAIN TERMINATION KIT.
KEY1=N1.
================== Physical/Chemical Properties ==================
HCC:V4
Spec Gravity:0.97 (WATER=1)
Viscosity:20 P
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE VISCOUS LIQUID
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AMINES, ALCOHOLS, WATER
Stability Condition to Avoid:CONTACT WITH AMINES, ALOCOHOLS, AND WATER.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE,
OXIDES OF NITROGEN, HYDROGEN CYANIDE, ISOCYANATES, OTHER TOXIC
VAPORS, GASES, ETC
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN AN INDUSTRIAL OR COMMERCIAL
FACILITY. DISPOSE OF COMPLETELY CURED (OR POLYMERIZED) MATERIAL IN
A SANITARY LANDFILL. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SPILL-KLEEN
CAGE:07TH4
CAGE:07TH4
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM POLYACRYLATE
CAS:25608-12-2
Fraction by Wt: 92-98%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 2-8%
Ingred Name:ACRYLIC ACID, 2-PROPENOIC ACID (IARC GROUP 3) *97-1*
CAS:79-10-7
RTECS #:AS3475000
Fraction by Wt: <0.08%
Other REC Limits:2 PPM = IC
OSHA PEL:10 PPM
ACGIH TLV:5.9 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER. SKIN: WASH W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:ANY APPROPRIATE MEDIA FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR POSITIVE PRESSURE, SCBA IN ANY CLOSED
SPACE WHEN FIGHTING FIRE.
Unusual Fire/Explosion Hazard:IN CONFINED CONDITIONS, A CONCENTRATED
FINE DUST OF MATERIAL IN AIR MAY CAUSE A DUST EXPLOSION IF IGNITED.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM(USING HEPA FILTER EQUIPPED SYSTEM)IF
POSSIBLE TO AVOID AIRBORNE DUST.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE.
Other Precautions:AVOID BREATHING POWDER. AVOID SKIN & EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED/EQUIVALENT W/HIGH
EFFICIENCY FILTER FOR PARTICULATE LEVELS ABOVE 0.05 MG/CUM.
Ventilation:RECOMMENDED AS APPROPRIATE TO CONTROL AIRBORNE DUST LEVELS
BELOW THE APPLICABLE EXPOSURE LIMITS.
Other Protective Equipment:NONE
Work Hygienic Practices:GOOD HOUSEKEEPING PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:OFF WHITE COLOR POWDER; ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Hazardous Decomposition Products:THERMAL: CO, CO2, HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-22750*COATING,EPOXY-POLYAMIDE
Kit Part:Y
CAGE:80592
CAGE:80592
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTANOL
RTECS #:EK8750000
ACGIH TLV:50PPM
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ISOBUTYL KETONE (HEXONE) (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM/75 STEL; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOPROPANOL
RTECS #:NT4370000
ACGIH TLV:400PPM
===================== Hazards Identification =====================
Effects of Overexposure:IRRI TO EYES NOSE THROAT NEAR ABOVE 200PPM.SKIN
IRRI CAN CAUSE DROWSINESS,DIZZINESS, COMA.
======================= First Aid Measures =======================
First Aid:FRESH AIR GIVE ART RESP CALL DOCTOR. FOR EYES,WATER FLUSH AND
CONTACT DOCTOR WASH SKIN. WASH CLOTHES BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point:45 F TCC 7 C TCC
Extinguishing Media:WATER FOG CO2 OR DRY CHEMICAL
Fire Fighting Procedures:USE AIR SUPPLIED EQUIPMENT FOR ENCLOSED
AREAS,COOL EXPOSED
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER ALL POSSIBLE. WIPE UP WITH
RAGS,SAWDUST,ETC. AVOID EXPOSURES TO SPARKS,FIRE OR HOT METAL
SURFACES.
======================Handling and Storage ======================
Handling and Storage Precautions:CLOSE CONTAINERS AVOID FLAMES,OPEN
LIGHTS,WELDING,SMOKING,SPARKS.
Other Precautions:MAINTAIN GOOD PERSONAL HYGIENE, DO NOT USE IN
CONFINED AREA. TANK OR PIT WITHOUT ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORG VAPOR CAN WHEN AIR CONTENT ADEQUATE AND
VAPOR CONC LESS 2% OR US
Ventilation:LOCAL EXHAUST AND MECHANICAL
Supplemental Safety and Health
*THIS PROUDCT IS A TWO-COMPONENT COATING. ANY MIXTURE OF COMPONENTS
WILL HAVE THE HAZARDS OF BOTH COMPONENTS.
================== Physical/Chemical Properties ==================
HCC:F2
Vapor Density:HEAV
Spec Gravity:SEESUP
Evaporation Rate & Reference:MODERATELY FAST
Solubility in Water:NA
Appearance and Odor:VISCOUS LIQUID WITH STRONG SOLVENT ODOR
Percent Volatiles by Volume:57.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NO
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINRATE OR USE APPROPRIATE BURIAL AREA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SODIUM ACETATE ANHYDROUS S3550, S0104
Preparer's Name:E. BRULL
CAGE:63415
CAGE:63415
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID, SODIUM SALT; (SODIUM ACETATE ANHYDROUS)
CAS:127-09-3
RTECS #:AJ4300010
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT: OR ACETIC ACID. GENTLY & THOROUGHLY WASH CONTAM
SKIN W/RUNNING WATER & NONABRASIVE SOAP. BE PARTICULARLY (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: CAREFUL TO CLEAN FOLDS, CREVICES, CREASES & GROIN.
COLD WATER MAY BE USED. COVER IRRITATED SKIN W/AN (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: EMOLLIENT. IF IRRIT PERSISTS, SEEK MED ATTN. WASH
CONTAM CLTHG BEFORE REUSING. SERIOUS SKIN CONTACT: WASH (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: W/A DISINFECTANT SOAP & COVER CONTAM SKIN
W/ANTI-BACTERIAL CREAM. SEEK MED ATTN. INHAL: ALLOW VICTIM TO (ING
6)
RTECS #:9999999ZZ
Ingred Name:ING 5: REST IN A WELL VENTILATED AREA. SEEK IMMED MED ATTN.
SERIOUS INHAL:NO ADDNL INFO. INGEST: REMOVE DENTURES (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: IF ANY. HAVE CONSCIOUS PERSON DRINK SEVERAL GLASSES
OF WATER OR MILK. INDUCE VOMITING BY STICKING FINGER (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: IN THROAT. LOWER HEAD SO THAT VOMIT WILL NOT REENTER
MOUTH & THROAT. NEVER GIVE AN UNCON PERSON ANYTHING (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: TO INGEST. SEEK MED ATTN. SERIOUS INGEST: NO ADDNL
INFO.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:STATE, LOCAL & REGIONAL AUTHORITY REQS. LARGE
SPILL: DATABASE CONTAINS NO ADDNL INFO IN CASE OF SPILL(ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: &/OR LEAK OF PROD. USE SHOVEL TO PUT MATL INTO
CONVENIENT WASTE DISPOSAL CNTNR. NEUTRALIZE RESIDUE W/A (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: DILUTE SOLN OF ACETIC ACID. FINISH CLEANING BY
SPREADING WATER ON CONTAM SURF & ALLOW TO EVACUATE THRU (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: SANITARY SYSTEM. PERSONAL PROT IN CASE OF LARGE
SPILL: ANSI APPRVD SPLASH GOGGS. FULL SUIT. NIOSH APPRVD(ING 14)
RTECS #:9999999ZZ
BE USED TO AVOID INHAL OF PROD. SUGGESTED PROT (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: CLTHG MIGHT NOT BE SUFFICIENT; CONSULT A SPECIALIST
BEFORE HANDLING THIS PRODUCT.
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR PRECS: COMBUSTIBLE MATERIALS SHOULD BE STORED
AWAY FROM EXTREME HEAT & AWAY FROM STRONG OXIDIZING AGENTS.
RTECS #:9999999ZZ
Ingred Name:OTHER PRECS: WHEN POSS. AVOID CONTACT W/SKIN & EYES. KEEP
AWAY FROM INCOMPATIBLES AS OXIDIZING AGENTS, ACIDS, MOISTURE.
RTECS #:9999999ZZ
Ingred Name:VENT: EXPOSURE LIMITS. IF USER OPERATIONS GENERATE DUST,
FUME OR MIST, USE VENT TO KEEP EXPOSURE TO AIRBORNE (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: CONTAMINANTS BELOW THE EXPOSURE LIMIT.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) 3530 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SLIGHTLY DANGEROUS TO DANGEROUS IN
CASE OF SKIN CONTACT (IRRITANT), OF EYE CONTACT (IRRITANT). VERY
SLIGHTLY TO SLIGHTLY DANGEROUS IN CASE OF INGESTION. THIS PRODUCT
MAY IRRITATE EYES AND SKIN UPON CO NTACT. CHRONIC: THERE IS NO
KNOWN EFFECT FROM CHRONIC EXPOSURE TO THIS PRODUCT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NEGLIGIBLE
Medical Cond Aggravated by Exposure:REPEATED OR PROLONGED EXPOSURE IS
NOT KNOWN TO AGGRAVATE MEDICAL CONDITION.
======================= First Aid Measures =======================
First Aid:EYES: CHECK FOR & REMOVE ANY CONTACT LENSES. IMMED FLUSH EYES
W/RUNNING WATER FOR AT LEAST 15 MIN KEEPING EYELIDS OPEN. COLD
WATER MAY BE USED. DO NOT USE EYE OINTMENT. SEEK MED ATTN. SKIN: IF
CHEM GO T ONTO CLOTHED PORTION OF BODY, REMOVE CONTAM CLOTHES AS
QUICKLY AS POSS, PROTECTING YOUR OWN HANDS & BODY. PLACE VICTIM
UNDER DELUGE SHOWER. IF CHEM TOUCHES VICTIM'S EXPOSED SKIN SUCH AS
(SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:SM FIRE:USE DRY CHEMS, CARBON DIOXIDE, WATER SPRAY
OR FOAM. LG FIRE:USE WATER SPRAY, FOG OR FOAM. DO NOT USE WATER
JET.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:PRODS OF COMBUST: CARBON OXIDES (CO,
CO*2). NON-FLAM IN PRESENCE OF OPEN FLAMES & SPKS, OF HEAT, OF
OXIDING MATLS, OF REDUCING MATLS, OF COMBUST MATLS, (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: USE APPROP TOOLS TO PUT SPILLED
SOLID IN CONVENIENT WASTE DISPOSAL CNTNR. IF NECESSARY, NEUTRALIZE
RESIDUE W/DILUTE SOLUTION OF ACETIC ACID. FINISH CLEANING BY
SPREADING WATER ON CONTAM S URFACE & DISPOSE OF ACCORDING TO FED,
(ING 10)
Neutralizing Agent:NEUTRALIZE THE RESIDUE WITH A DILUTE SOLUTION OF
ACETIC ACID.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR DRY. KEEP IN A COOL PLACE.
GROUND ALL EQUIP CONTAINING MATL. KEEP CNTNR TIGHTLY CLOSED. KEEP
IN A COOL, WELL-VENTILATED PLACE. (ING 16)
Other Precautions:KEEP AWAY FROM HEAT. KEEP AWAY FROM SOURCES OF IGNIT.
EMPTY CNTNRS POSE A FIRE RISK; EVAPORATE THE RESIDUE UNDER A FUME
HOOD. GROUND ALL EQUIP CONTAINING MATL. DO NOT BREATHE DUST. IF YOU
FEEL UNWELL, SEEK MED ATTN & SHOW LABEL WHEN(ING 17)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST RESPIRATOR. BE SURE TO USE A NIOSH APPROVED
RESPIRATOR.
Ventilation:USE PROCESS ENCLOSURES, LOCAL EXHAUST VENT OR OTHER
ENGINEERING CONTROLS TO KEEP AIRBORNE LEVELS BELOW RECOM (ING 18)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . LAB
COAT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH (1% SOLN/WATER): 11. EXPLO HAZ: OF MOISTURE. NO SPECIFIC INFO IS
AVAIL IN DATABASE REGARDING PROD'S RISK OF EXPLOSION IN PRESENCE OF
VARIOUS MATLS. COMBUSTIBLE WHEN EXPOSED TO HEAT OR FLAME. WHEN H
EATED TO DECOMP IT EMITS TOX FUMES. FIRST AID PROC: HANDS:
NEUTRALIZE EXPOSED SKIN W/DILUTE SOLN OF BORIC ACID (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:M.P/F.P Text:615F,324C
Spec Gravity:1.53 (H*2O=1)
pH:SUPDAT
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS SOLID (EFFORESCENT CRYSTALS SOLID);
ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HIGHLY REACTIVE W/OXIDIZING AGENTS. SLIGHTLY REACTIVE TO REACTIVE
W/ACIDS, MOISTURE. NON-CORR IN PRESENCE OF GLASS.
Stability Condition to Avoid:HYGROSCOPIC; KEEP CONTAINER TIGHTLY
CLOSED.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE TO PROCESS, IF POSSIBLE. CONSULT YOUR
FEDERAL, STATE, LOCAL AND REGIONAL AUTHORITIES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EC CLEANER/DEGREASER
CAGE:0VE73
CAGE:0VE73
============= Composition/Information on Ingredients =============
Ingred Name:NO HAZARDOUS INGREDIENTS, BIODEGRADEABLE.
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NA
ACGIH TLV:NA
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MILD IRRITATION. SKIN: MILD
IRRITATION W/PROLONGED CONTACT. CHRONIC EFFECTS NOT KNOWN.
Medical Cond Aggravated by Exposure:NOT KNOWN
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY WATER 15 MINUTES. SKIN: FLUSH W/PLENTY
WATER. INGESTION: DRINK PLENTY MILK/WATER TO DILUTE. SEEK MEDICAL
AID IF NECESSARY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NA (WATER SOLUTION)
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP SMALL SPILLS W/ABSORBENT & SHOVEL INTO
WASTE CONTAINER. LARGE: RECOVER LIQUID FOR REPROCESSING OR
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT DRUM FROM DAMAGE, FREEZING OR
INTENSE HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:USE ADEQUATE VENTILATION.
Other Protective Equipment:RUBBER APRON & BOOTS, SAFETY SHOWER &
EYEWASH STATIONS.
Supplemental Safety and Health
*PH OF 5% SOLUTION = 9.6. PH OF NEAT SOLUTION = <12.5
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SIMILAR H2O
Vapor Pres:SAME WATER
Vapor Density:1.0 G/CC
pH:<12.5
Appearance and Odor:HAZY LIQUID, MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, MINERAL ACIDS.
Hazardous Decomposition Products:NOTHING HAZARDOUS.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE, LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:E-Z-PAQUE, CAT #750 AND SOLOPAKE, CAT #760
CAGE:JO796
CAGE:25969
CAGE:JO796
============= Composition/Information on Ingredients =============
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:UNIDENTIFIED COMPONENTS(USED TO AID SUSPENDABILITY &
FLUIDITY),TYPES NOT IDENTIFIED.
Fraction by Wt: UNK
===================== Hazards Identification =====================
Effects of Overexposure:IN RARE CASES FOLLOWING REPEATED
ADMNSTRTION,SEVERE STOMACH CRAMP & DIARR MAY OCCUR;NO SYMPTMS EYES.
======================= First Aid Measures =======================
First Aid:ALTHOUGH NON-IRRITATION,TAKE NORMAL PRECAUTIONARY MEASURES
WASHING OFF THE SKIN W/WATER AND FLUSH EYES WITH WATER.IF
SWALLOWED,FREQUENT CONSUMPTION OF DRINKING WATER
REQUIRED.CONSTIPATION MAY OCCUR AF TER NORMAL INGESTION OF BARIUM
SULFATE SUSPENSION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:NOT KNOWN
Unusual Fire/Explosion Hazard:NONE NOTED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE RESPIRATORY PROTECTION TO AVOID INHALATION
OF DUST.SMALL SPILL:NORMAL CLEAN UP WITH WATER:LG SPILL:COLLECT
MATL BY SWEEPING OR VACUUMING & PLACE IN COVERED DRUMS.FLUSH AWAY
TO SEWER(THE RESIDUE)W/ LG AMTS OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:NONE INDICATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS & LEGS.
Supplemental Safety and Health
MSDS FM MFR DATED:AUGUST 1985;PHILADELPHIA,MEDICAL MANAGES THE ITEM FOR
P/N E-Z-PAQUE,750 & VETERAN ADMINISTRATION MANAGES FOR P/N
SOLOPAKE,760,SAME NSN; HOWEVER, THE MSDS COVERS BOTH ITEMS.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:SLIGHT
Appearance and Odor:PRODUCT IS RADIOPAQUE SUSPENSION.SLIGHT FRUIT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT KNOWN
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EL-324-SC HARDENER
Kit Part:Y
CAGE:66058
CAGE:66058
============= Composition/Information on Ingredients =============
Ingred Name:POLYAMIDE RESIN
CAS:68410-23-1
Fraction by Wt: 15-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM BORATED SILICATE; (SODIUM BOROSILICATE MICROSPHERES)
CAS:50815-87-7
Fraction by Wt: <40%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FATTY AMIDOAMINE; (FATTY AMIDOAMINE RESIN)
CAS:68991-84-4
Fraction by Wt: 15-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STEARIC ACID, CALCIUM SALT; (CALCIUM STEARATE)
CAS:1592-23-0
RTECS #:WI3000000
Fraction by Wt: 15-20%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:REDNESS AND SWELLING OF AFFECTED
AREAS. POSSIBLE ALLERGIC RESPONSE, METHEMOGLOBINEMIA AND LIVER
DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT DETERMINED.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CONTACT MD.
SKIN: WASH WITH MILD SOAP AND WATER. INHALATION: REMOVE FROM
CONTAMINATED AREA TO FRESH AIR. INGESTION: DO NOT INDUCE VOMITING.
CONTACT MD.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>300F,>149C
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP IN ABSORBENT MATERIAL OR SCRAPE UP.
SCRUB WITH 5% ACETIC ACID TO EMULSIFY. RINSE WITH VERY HOT WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT AMBIENT TEMPERATURE IN A WELL
VENTILATED AREA AWAY FROM EXCESSIVE HEAT OR OPEN FLAMES.
Other Precautions:NONE KNOWN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY NEEDED. USE NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST RECOMMENDED. MECHANICAL (GENERAL): USUALLY IS
ADEQUATE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
CLEAN, BODY COVERING CLOTHING.
Work Hygienic Practices:PRACTICE GOOD HYGIENE AND USE WITH CAUTION TO
AVOID EYE OR SKIN CONTACT.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:0.45 (H*2O=1)
Solubility in Water:SLIGHT
Appearance and Odor:BLACK SYNTACTIC WITH MILD AMMONIACAL ODOR.
Percent Volatiles by Volume:<0.01
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS.
Stability Condition to Avoid:REACTIONS WITH EPOXIDES UNDER UNCONTROLLED
CIRCUMSTANCES.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN ADEQUATE INCINERATOR OR BURY IN LANDFILL
IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:83-6-105452 POWER-CLEAN BLANKET WASH
CAGE:FO004
CAGE:FO004
CAGE:09177
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 2-5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:VOL ORGANIC CMPD: 6.5 LBS/GAL OR 778.9 G/L (CALCULATED)
RTECS #:9999999VO
Ingred Name:ISOPARAFFINIC HYDROCARBONS (NAPHTHA PETROLEUM),
HYDROTREATED HEAVY, NON AROMATIC HEAVY NAPHTHA) ISOPAR G
CAS:64742-48-9
Fraction by Wt: 95-98%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: IRRITATION &
DERMATITIS. INHALATION: UPPER RESPIRATORY TRACT IRRITATION.
INGESTION: TOXIC & IRRITATING TO GI TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DEFATTING, HEDACHE, NAUSEA,
NARCOSIS, COMA.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/COPIOUS AMOUNTS OF WATER FOR 10-15 MINS. SKIN:
WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. RESTORE
BREATHING IF NEEDED. INGESTION: DON'T INDUCE VOMITING. ASPIRATION
HAZARD. GIV E 1-2 TABLESPOONS VEGETABLE OIL. OBTAINMEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:110F
Lower Limits:0.8
Upper Limits:6
Extinguishing Media:CO2, FOAM, DRY CHEMICAL
Fire Fighting Procedures:DON'T USE WATER, IT WILL SPREAD SOLVENT FIRES.
Unusual Fire/Explosion Hazard:VAPOR BUILD-UP IN CONFINED
AREAS/CONTAINERS CAN CAUSE EXPLOSIVE MIXTURES IN AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/RAGS/SIMILAR ABSORBING MATERIAL. WEAR
ORGANIC VAPOR MASK IF TLV EXCEEDED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN ORIGINAL CONTAINER, TIGHTLY
CLOSED. READ & FOLLOW PRECAUTIONS ON CONTAINER LABEL. FOR
COMMERCIAL/INDUSTRIAL USE ONLY.
Other Precautions:DON'T REUSE CONTAINER. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHAUST: ONLY TO REMAIN <50% OF TLV
Other Protective Equipment:APRON, EYEWASH STATION, SAFETY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:316-348F
Vapor Density:4.7
Spec Gravity:0.7785
Evaporation Rate & Reference:(BU AC = 1): 3.5
Solubility in Water:INSOLUBLE
Appearance and Odor:VIOLET LIQUID W/NAPHTHA ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL CLASSIFIED AS EPA HAZARDOUS DUE TO
FLASH POINT. DISPOSE OF AS HAZARDOUS WASTE IAW/FEDERAL, STATE &
LOCAL REGULATIONS. DON'T POUR DOWN COMMON DRAIN. UN1993 & NA1993
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GL-5 GEAR OIL, 85W-140
CAGE:OO165
CAGE:OO165
CAGE:60098
============= Composition/Information on Ingredients =============
Ingred Name:REFINED PETROLEUM OIL; (REFINED PETROLEUM PRODUCTS)
Fraction by Wt: 90-95%
Ingred Name:ADDITIVES
Fraction by Wt: 4-6%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: 1 PT TO 1 QT IS APPROXIMATE
LETHAL ORAL DOSE FOR 150# HUMAN. CHRONIC: PROLONGED &/OR FREQUENT
CONTACT MAY CAUSE DRYING, CRACKING OR FOLLICULITIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF
RESP) . INGEST: CALL MD IMMED . EYES: IMMED FLUSH WITH POTABLE
WATER FOR A MINIMUM OF 15 MIN, SEEK ASSISTANCE FROM MD . SKIN:
FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL MD .
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>445F,>229C
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WATER MAY CAUSE FROTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION OR HEAT, PROVIDE
ADEQUATE VENTILATION, CONTAIN LEAK. ABSORB SMALL SPILLS WITH
SUITABLE MATERIAL SUCH AS RAGS, STRAW/SAND.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NONE. NIOSH/MSHA APPROVED HIGH
VAPOR/MIST CONCENTRATION RESPIRATOR.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV: 0.9042-0.8927(H*2O=1).
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>400F,>204C
Spec Gravity:SUPP DATA
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK GREEN, MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:AVOID CONTACT WITH STRONG OXIDANTS.
Hazardous Decomposition Products:CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DETERMINE IF HAZARDOUS @ TIME OF DISPOSAL.
COMPLY W/CURRENT FEDERAL, STATE & LOCAL LAWS & REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:829 3144 KODAK T-960-02 DEVELOPER REPLENISHER, PART E
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CARBONATE
CAS:5968-11-6
Fraction by Wt: 90-95%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM BICARBONATE
CAS:144-55-8
RTECS #:VZ0950000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 1600-3200 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: EXPECTED TO BE LOW HAZARD
FOR RECOMMENDED HANDLING. EYES: CAUSES IRRITATION. SKIN: CAUSES
IRRITATION. INGESTION: HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INGESTION: MAY CAUSE BURNS OF THE
GASTROINTESTINAL TRACT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION-IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES-IMMEDIATELY FLUSH WITH PLENTY
OF WATER FOR AT LEAST 15 MIN. GET MEDICAL ATTENTION.
SKIN-IMMEDIATELY REMOVE CONTAMINATED CLOTHING & SHOES & WASH WITH
SOAP & PLENTY OF WATER. GET MEDCIAL ATTENTION IF SYMPTOMS OCCUR.
INGESTED-DO NOT INDUCE VOMITING. GIVE VICTIM A GLASS OF WATER. CALL
A PHYSICIAN/POISON CTRL.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE APPROPIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
OTHERWISE, SWEEP UP AND PLACE IN A CONTAINER FOR CHEMICAL WASTE.
CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP AWAY FROM
INCOMPATIBLE SUBSTANCES.
Other Precautions:AVOID CONTACT WITH EYES, SKIN AND CLOTHING. USE WITH
ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EYE BATH, SAFETY SHOWER, WASHING FACILITIES.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:NEGLIGIBLE
Solubility in Water:APPRECIABLE
Appearance and Odor:SOLID. WHITE. ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:STABLE.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE AMOUNTS
OF WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LDX TONER, P/N 6R152
CAGE:26921
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE, ACRYLATE COPOLYMER
CAS:25213-39-2
Fraction by Wt: 80 - 85%
Other REC Limits:NONE SPECIFIED
Ingred Name:POLY VINYL BUTYRAL RESIN
CAS:63148-65-2
Fraction by Wt: 5 - 10%
Other REC Limits:NONE SPECIFIED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 5 - 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 > 16 G/KG (RAT), NON-TOXIC
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NOT AN IRRITANT FOR EYES OR SKIN.
Effects of Overexposure:SEE HEALTH HAZARDS
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER. SKIN: WASH WITH SOAP AND WATER.
INHALATION: REMOVE FROM EXPOSURE. INGESTION: DILUTE STOMACH
CONTENTS WITH SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER, DRY CHEMICAL, CARBON DIOXIDE, OR FOAM.
Fire Fighting Procedures:AVIOD INHALATION OF SMOKE. WEAR PROTECTIVE
CLOTHING AND SELF-CONTAINED BREATHING APPARATUS
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. WHEN
DISPERSED IN AIR, IT CAN FORM EXPLOSIVE MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR VACUUM SPILLED TONER AND CAREFULLY
TRANSFER INTO A SEALABLE WASTE CONTAINER. SWEEP SLOWLY TO MINIMIZE
GENERATION OF DUST DURING CLEAN-UP. RESIDUE CAN BE REMOVED WITH
SOAP AND COLD WATER.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:AVOID PROLONGED INHALATION OF EXCESSIVE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NONE
Other Protective Equipment:NONE
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:APPROX. 1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER WITH FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXTREME HEAT, SPARKS, OR FLAME
Hazardous Decomposition Products:TOXIC SUBSTANCES OF UNKNOWN
COMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS. INCINERATE ONLY IN A CLOSED CONTAINER.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:BRAYCO MICRONIC 771
Preparer's Name:KAREL WRIGHT
CAGE:HO868
CAGE:HO868
CAGE:98308
============= Composition/Information on Ingredients =============
Ingred Name:TRICRESYLPHOSPHATE
CAS:1330-78-5
RTECS #:TD0175000
Fraction by Wt: <0.8%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE MOD EYE IRRIT. PRLNGD/RPTD
SKIN CNTCT MAY CAUSE SKIN IRRITATION, DEFATTING. AVOID INHALATION
OF MISTS OR VAPORS ABOVE RECOMMENDED EXPOSURE LIMIT;
NASAL/RESPIRATORY IRRITATION MAY RESULT. TRI CRESYL PHOSPHATE HAS
BEEN SHOWN TO CAUSE NERVE DAMAGE IF INGESTED OR INHALED IN
SUFFICENT QTYS; (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CHOLINESTERASE INHIBITION HAS ALSO
BEEN PRODUCED IN ANIMALS. MODERATE EYE IRRITATION, REDNESS,
TEARING. SKIN IRRITATION, DEFATTING, DERMATITUS.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH LARGE AMOUNTS OF CLEAN WATER FOR AT LEAST 15
MIN. CONTACT A PHYSICIAN IF IRRITATION PERSISTS. SKIN:REMOVE
CONTAMINATED CLOTHING. WIPE MATERIAL FROM SKIN. WASH THOROUGHLY
WITH SOAP AND WATER. INHAL:REMOVE FROM AREA OF EXPOSURE.
ADMINISTER OXYGEN IF DEEMED NECESSARY. INGEST:DO NOT INDUCE
VOMITING; ASPIRATION HAZARD. CONSULT A PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:360F,182C
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER AS FOG OR SPRAY TO COOL FIRE
EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:EMPTY CONTAINERS MAY RETAIN PRODUCT
RESIDUE OR VAPORS WHICH CAN IGNITE EXPLOSIVELY; DO NOT CUT, DRILL
OR WELD ON OR NEAR FULL OR EMPTY CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT PERMIT OIL TO ENTER STREAMS, SEWERS OR
OTHER WATERWAYS. DIKE LARGE SPILLS AND ELIMINATE LEAKS. ABSORB WITH
DRY INERT MATERIAL AND STORE IN CLOSED CONTAINERS UNTIL DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MAINTAIN AMBIENT TEMP. AVOID
PRLNGD/RPTD BRTHG OF VAPS, MISTS, FUMES. KEEP CNTNR TIGHTLY CLSD.
DO NOT STORE NEAR HEAT/FLAME/STRONG OXIDANTS.
Other Precautions:MAINTAIN ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CHEMICAL CARTRIDGE RESPIRATOR OR SUPPLIED AIR
RESPIRATORY EQUIPMENT AS REQUIRED FOR CONCENTRATION EXCEEDING
OCCUPATIONAL EXPOSURE RECOMMENDATION.
Ventilation:NOT NORMALLY REQUIRED. LOCAL EXHAUST, IN ADDITION TO
GENERAL VENT WHEN OCCUPATIONAL EXPOSURE LIMIT IS EXCEEDED.
Other Protective Equipment:IMPERVIOUS GARMENTS AS REQUIRED.
Work Hygienic Practices:DO NOT WEAR CONTAMINATED CLOTHING. LAUNDER
BEFORE RE-USE OR DISCARD.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>600F,>316C
Spec Gravity:0.85(H*2O=1)
Evaporation Rate & Reference:<0.01 (BUAC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PALE YELLOW FLUID; PETROLEUM ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXYDIZING AGENTS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SMOKE, FUMES, CO, CO*2; MINOR AMOUNTS
OF VARIOUS HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL RECOVERED MATL SHOULD BE PACKAGED, LABELED,
TRANSPORTED, & DISP OF OR RECLAIMED IN CONFORMANCE WITH GOOD
ENGINEERING PRACTICES. DISPOSE OF BY METHOD IN COMPLIANCE WITH
LOCAL, STATE, & FEDERAL REGU LATIONS REGARDING HEALTH, AIR & WATER
POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MALEIC ACID BUFFER, 444923
CAGE:64595
CAGE:64595
============= Composition/Information on Ingredients =============
Ingred Name:MALEIC ACID (SARA III)
CAS:110-16-7
RTECS #:OM9625000
Fraction by Wt: 15-17%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS MIXTURE HAS NOT BEEN TESTED AS A
WHOLE. THE HEALTH EFFECTS DESCRIBED HERE ARE BASED ON THE
TOXICOLOGICAL PROPERTIES OF THE INDIVIDUAL HAZARDOUS INGREDIENT.
ACUTE/CHRONIC: MAY CAUSE IRRITATION OF THE NOSE, THROAT & SKIN, &
BURNS OF THEEYES. ADDITIONAL EFFECTS MAY INCLUDE COUGHING, SWELLING
OF THE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SKIN & EYES. MAY AFFECT THE KIDNEY &
LIVER.
Medical Cond Aggravated by Exposure:NONE DOCUMENTED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. IF BRTHG HAS STOPPED, PERFORM ARTF
RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. GET MED ATTN IMMED.
SKIN:FLUSH W/COPIOUS AMTS OF WATER FOR AT LEAST 15 MINS. REMOVE
CONTAMD CLTHG/SH OES. GET MED ATTN IMMED. EYES:FLUSH W/COPIOUS AMTS
OF WATER FOR AT LEAST 15 MINS. ASSURE ADEQ FLUSHING BY SEPARATING
EYELIDS W/FINGERS. GET MED ATTN IMMED. INGEST:WASH OUT MOUTH
W/WATER. GET (SUP DAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICALS, CARBON DIOXIDE, WATER OR REGULAR
SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PRODS OF COMBUST MAY INCL OXIDES OF
CARBON. DEPENDING UPON FIRE CNDTNS, COMBUST PRODS MAY BE PRDCED
WHICH RANGE FROM IRRITANTS & ASPHYXIANTS TO (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP W/INERT MATERIAL. DISPOSE ACCORDING TO
LOCAL, STATE & FEDERAL REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLE
SUBSTANCES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:GENERAL ROOM VENTILATION IS SATISFACTORY FOR NORMAL USAGE.
Other Protective Equipment:WEAR APPROPRIATE PROTECTIVE CLOTHING TO
AVOID SKIN CONTACT. ANSI APPRVD EYEWASH FOUNTAIN & EMERGENCY SHOWER
.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:ACUTELY TOXIC MATERIAL WHICH MAY CAUSE DAMAGE TO ORGAN
SYSTEMS INCLUDING LUNGS, BLOOD, LIVER, KIDNEYS AND THE CENTRAL
NERVOUS SYSTEM. FIRST AID PROC:MEDICAL ATTENTION IMMEDIATELY.
================== Physical/Chemical Properties ==================
HCC:T6
Solubility in Water:COMPLETE
Appearance and Odor:WHITE POWDER; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS & OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE ACCORDING TO LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SCRUB BRITE SOFT CLEANSER
CAGE:69375
CAGE:69375
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM CARBONATE; (CARBONIC ACID CALCIUM SALT (1:1))
CAS:471-34-1
RTECS #:FF9335000
< Wt:50.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:DIPROPYLENE GLYCOL METHYL ETHER; ((2-METHOXYMETHYLETHOXY)
PROPANOL)
CAS:34590-94-8
RTECS #:JM1575000
< Wt:10.
Other REC Limits:N/K
OSHA PEL:600 MG/M3;100 PPM
OSHA STEL:N/K
ACGIH TLV:606 MG/M3;100 PPM
ACGIH STEL:909 MG/M3;150 PPM
Ingred Name:PRIMARY ALKANE SULFONATE; (1-OCTANESULFONIC ACID, SODIUM
SALT)
CAS:5324-84-5
< Wt:10.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:SODIUM CARBONATE; (CARBONIC ACID SODIUM SALT)
CAS:497-19-8
RTECS #:VZ4050000
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:D-LIMONENE; ((R-) 1-METHYL-4-(METHYLETHENYL)-CYCLOHEXENE).
(OR INGREDIENT 6)
CAS:5989-27-5
RTECS #:GW6360000
< Wt:10.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:TERPENES AND TERPENOIDS, SWEET ORANGE-OIL
CAS:68647-72-3
< Wt:10.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:ETHANOL, 2,2'-IMINOBIS-, N-COCO ALKYL DERIVS.; (COCAMIDE
DEA). (2,2'-IMINOBISETHANOL, N-COCO ALKYL DERIVS.)
CAS:61791-31-9
< Wt:10.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:DETERGENT RANGE ALCOHOL ETHOXYLATE;
(ALPHA-UNDECYL-OMEGA-HYDROXY-POLY (OXY-1,2-ETHANEDIYL))
CAS:34398-01-1
< Wt:10.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:QUARTZ; (CRYSTALLINE SILICA)
CAS:14808-60-7
RTECS #:VV7330000
< Wt:1.
Other REC Limits:N/K
OSHA PEL:see Table Z-3
OSHA STEL:N/K
ACGIH TLV:0.1 MG/M3
ACGIH STEL:N/K
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:THIS PROD CAN AFFECT BODY IF IT
CONTACTS SKIN/EYES, IS INHALED/INGESTED. SKIN: NOT A PRIMARY SKIN
IRRITANT. PRLNG/RPTD SKIN CONT MAY CAUSE DRY SKIN. EYES: PRIMARY
EYE IRRITANT. INGEST: MAY CAUSE IRRIT OF MOUTH & THROAT, UPSET
STOM, NAUS, VOMIT, & DIARR. INHAL: MAY CAUSE IRRIT OF NOSE, THROAT,
& LUNGS. NOTES: INHAL EFTS OTHER THAN RESP IRRIT, & SKIN ABSORPTION
EFTS HAVE NOT BEEN DETERMINED. INHAL & SKIN ABSORPTION EFTS OF
INDIVIDUAL INGS ARE NOTED BELOW. A PREDICTION AS TO WHETHER THESE
EFTS WILL BE EXHIBITED BY PROD AS A WHOLE IS DEPENDENT ON
EVALUATION OF PROD'S USE & EXTENT & DURATION OF EXP OS. (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC
MONOGRAPHS, VOLUME 68, PAGE 41, 1997: GROUP 1. NTP 8TH ANNUAL
REPORT ON CARCINOGENS, 1998: REASONABLY ANTICIPATED TO BE HUMAN
CARCINOGEN. HUMAN: LUNG.
Effects of Overexposure:HLTH HAZ: INHAL OF CRYSTALLINE SILICA DUSTS MAY
CAUSE LUNG DMG (SILICOSIS). CRYSTALLINE SILICA IS AN IARC CLASS 2A
CARCIN (PROBABLY CARCIN TO HUMANS). OSHA PEL & ACGIH TLV FOR
CRYSTALLINE SILICA (QUAR TZ) RESP DUST ARE 0.1 MG/M3. SKIN
ABSORPTION & INHAL OVEREXP TO VAPS OF DIPROPYLENE GLYCOL MONOMETHYL
ETHER MAY CAUSE ANESTH/NARCOTIC EFTS. RPTD EXCESS EXPOS MAY CAUSE
LIVER/POSS KIDNEY EFTS. ACGIH TL V & OSHA PEL ARE 100 PPM. (OSHA
STEL & ACGIH STEL ARE 150 PPM.) ACGIH INDICATES THAT DIPROPYLENE
GLYCOL MONOMETHYL ETHER IS ABSORBED THRU SKIN. PRLNG SKIN CONT
W/D-LIMONENE MAY CAUSE PHOTOSENSITIVITY. (SUP DAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN, EYE, AND
RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:SKIN: RINSE THORO W/WATER. EYES: REMOVE CONT LENSES. RINSE
W/GENTLE STREAM OF LUKEWARM WATER FOR AT LEAST 15 MINS, HOLDING
EYELIDS OPEN. IF IRRIT DEVELOPS, GET MED ADVICE BY CALLING EMER
CTR/HOSPITAL EMER ROOM. INGEST: IF VICTIM IS A CHILD, GIVE 4-8 OZ
OF WATER. FOR ADULTS, GIVE 12 OZ OF WATER. DO NOT INDUCE VOMIT WHEN
PROD IS SWALLOWED. IF V OMIT OCCURS SPONT, KEEP VICTIM IN UPRIGHT
OF MSDS OR LOC/REGIONAL POIS CTL CTR/HOSPITAL EMER ROOM. INHAL:
REMOVE TO FRESH AIR. (OTHER INFO)
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAM/COMBUST
Extinguishing Media:USE WATER SPRAY, FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:WEAR NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE EQUIPMENT . COOL CONTAINERS WITH
WATER.
Unusual Fire/Explosion Hazard:NO EXPLOSION HAZARD IDENTIFIED. PRODUCTS
OF COMBUSTION: CO, CO*2, NO*2, COCL*2, HCL, SMOKE, SOOT,
UNIDENTIFIED ORGANICS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT
BOOTS, PROTECTIVE CLOTHING). CONTAIN/DIKE SPILL TO PREVENT
ENVIRONMENTAL RELEASE.
======================Handling and Storage ======================
Handling and Storage Precautions:THIS PROD IS A CONSUMER PROD. TO THE
EXTENT PROD IS USED IN A FASHION TYPICAL TO THAT OF A CONSUMER,
PROT MEASURES, W/EXCEPTION OF THOSE INDICATED ON LABEL, ARE NOT
NORM NEC. WHERE USE CNDTNS &/OR EXT ENT & DURATION OF EXPOS DIFFER
FROM TYPICAL CONSUMER USE, HOWEVER, APPROP PROT MEASURES (OTHER
PREC)
Other Precautions:HNDLG/STOR PREC: TO PREVENT EYE & PROLONGED SKIN CONT
INHALATION EXPOSURE (ENGINEERING CONTROLS, NIOSH APPROVED
RESPIRATORY PROTECTION APPROPRIATE FOR THE HAZARD PRESENTED) ARE
RECOMMENDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:ENGINEERING CONTROLS APPROPRIATE FOR HAZARD PRESENTED.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER .
Work Hygienic Practices:FOR GOOD PERSONAL HYGIENE, INSURE PROMPT
REMOVAL FROM SKIN AND CLOTHING.
Supplemental Safety and Health
EFTS OF OVEREXP: RPTD DAILY ORAL DOSING OF RATS & DOGS W/D-LIMONENE
CAUSED KIDNEY EFTS. INHAL OF D-LIMONENE VAPS MAY CAUSE NERV SYS
DEPRESS & MUC MEMB IRRIT. DETERGENT RANGE ALCOHOL ETHOXYLATE IS
SLIG HTLY TOX IF ABSORBED THRU SKIN.
================== Physical/Chemical Properties ==================
Spec Gravity:1.25 (H*2O=1)
pH:10.4 - 11.0
Appearance and Odor:OPAQUE, CREAM-COLORED LIQUID WITH A SPICE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH ACIDS, STRONG OXIDIZERS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT, FLAME.
=================== Toxicological Information===================
Toxicological Information:SEE INGREDIENTS. (S)=SKIN;
LD50=DERMAL.RABBIT; LC50=INHALATION,RAT; DNA-DATA NOT AVAILABLE;
NA-NOT APPLICALBE.
===================== Ecological Information =====================
Ecological:NO INFORMATION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:DOT PROPER SHIPPING NAME: PAINT. DOT HAZARD
CLASS: 3. DOT UN/NA NUMBER: 1263. HAZARD SUBCLASS: NA. IMO: NA.
PACKING GROUP: III.
===================== Regulatory Information =====================
SARA Title III Information:BUTYL ALCOHOL IS SUBJECT TO REPORTING
REQUIREMENTS OF SARA (40CFR 355 AND 372). HIGH FLASH NAPHTHA IS
SUBJECT TO REPORTING REQUIREMENTS OF CERCLA(40CFR 302).
Federal Regulatory Information:+PIGMENT CONTENT IS DEPENDENT ON COLOR.
ALL INGREDS ARE ON TSCA INVENTORY OR ARE EXEMPT. U.S. FED REGS: AS
FOLLOWS - OSHA: HAZARDUS BY DEFINITION OF HAZARD COMMUNICATION
STANDARD (29 CFR 1910.1200). I NTERNATIONAL REGS: AS FOLLOWS -
CANADIAN WHMIS: THIS MSDS HAS BEEN PREPARED IN COMPLIANCE WITH
CONTROLLED PRODUCT REGULATIONS EXCEPT FOR USE OF THE 16 HEADINGS.
CANADIAN WHMIS CLASS: NO INFORMATION AV AILABLE.
State Regulatory Information:**CALIF. TITLE 26:22-1200 (PROP 65).
WARNING: THIS PRODUCT CONTAINS CHEM KNOWN TO STATE OF CALIFORNIA TO
CAUSE CANCER. #CALIF. TITLE 26:22-1200 (PROP 65). WARNING:THIS PROD
CNTNS CHEM KNOWN TO STATE O F CALIFORNIA TO CAUSE BIRTH
DEFECTS/OTHER REPRODUCTIVE HARM. NEW JERSEY RIGHT-TO-KNOW: NO
NON-HAZARDOUS MATLS ARE AMONG TOP 5 INGREDIENTS. PENNSYLVANIA
RIGHT-TO-KNOW: NO NON-HAZARDOUS INGREDIENTS ARE PRESENT AT GREATER
THAN 3%.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NC-830 SOLDER PASTE
Preparer's Name:D BERNIER
CAGE:GO345
CAGE:GO345
CAGE:75297
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA 313) (CERCLA)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 33.3%
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15MG/M3 DUST
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 56.7%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:POLYMERIZED ROSIN; (MODIFIED ROSIN)
CAS:65997-05-9
Fraction by Wt: <7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHANOL, 2-(2-BUTOXYETHOXY)-; (DIETHYLENE GLYCOL BUTYL
ETHER)
CAS:112-34-5
RTECS #:KJ9100000
Fraction by Wt: <2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SURFACTANTS (INCLUDING INGREDIENTS #6 AND #7)
Fraction by Wt: <2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WETTING AGENTS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BINDERS, TYPE UNSPECIFIED; (BINDERS)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND:5 G/LITER
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:FLUX FUMES DURING
SOLDERING MAY CAUSE IRRIT & DMG OF MUC MEMBS & RESP SYS. SKIN:POSS
LOC IRRIT. SKIN ABSORP:NONE. EYE:IRRIT FROM CONT W/SMK FROM
SOLDERING. INGEST:MOST OF SOLDERPASTE WILLPASS THRU BODY
UNABSORBED. LEAD THAT ISABSORBED IS CAUGHT BY LIVER, &, IN PART,
EXCRETED IN BILE. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:CHRONIC:LEAD APPEARS ON NAVY OCCUP CHEM REPRO
HAZ LIST. SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS
CONCERNING LASTEST HAZ LIST INFO & SAFE HNDLG & EXPOS INFO
.PRLNGD/RPTD CONT W/PASTE CAN CAUSE RASH. BRTHG FUMES DURING
SOLDERING MAY CAUSE RESP IRRIT, HDCH & IRRIT OF MUC MEMBS. RPTD
INGEST OF LEAD (SUP DAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS OF THE
LUNGS, DISEASES OF THE BLOOD AND BLOOD-FORMING ORGANS, KIDNEYS,
NERVES & POSSIBLY REPRODUCTIVE SYSTEM.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES
AND GET MEDICAL ATTENTION. SKIN:WASH THOROUGHLY WITH SOAP AND
WATER. INHALATION:REMOVE VICTIM TO FRESH AIR. INGESTION:GASTRIC
LAVAGE (STOMAC H PUMPING) IF PHYSICIAN ADVISES. GET PROMPT MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE. HAZARDOUS COMBUSTION
PRODUCTS:CARBON MONOXIDE, CARBON DIOXIDE, LEAD OXIDE FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP PASTE AND DEPOSIT IN APPROPRIATE
CONTAINERS. CLEAN UP RESIDUAL WITH ISOPROPANOL OR DETERGENT WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CAUTION:EMPTY CONTAINERS MAY CONTAIN
PRODUCT RESIDUE. OBSERVE ALL LABEL PRECAUTIONS.
Other Precautions:STORE AT OR NEAR 70F (21C) IN CLOSED CONTAINERS. WASH
HANDS AFTER HANDLING SOLDERPASTE AND BEFORE EATING OR SMOKING. CARE
SHOULD BE TAKEN TO REMOVE SOLDERPASTE FROM UNDER FINGERNAILS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USUALLY NOT REQUIRED. WHEN VENTILATION IS NOT
ADEQUATE TO REMOVE SMOKE FROM THE BREATHING ROOM, A NIOSH APPROVED
CARTRIDGE TYPE RESPIRATOR SHOULD BE WORN.
Ventilation:PROVIDE ADEQUATE VENTILATION (GENERAL AND/OR LOCAL) TO MEET
TLV REQUIREMENTS.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . DO NOT WEAR CONTAMINATED CLOTHING OR SHOES HOME.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING
SOLDERPASTE.
Supplemental Safety and Health
HAZ DECOMP PRODS:ACIDS & TERPENES. NO LEAD IS DETECTED IN FUMES FROM
SOLDERING BELOW 1000F (537C). EFTS OF OVEREXP:CAN RSLT IN SYS
POISONING. PROD CNTNS LEAD WHICH IS KNOWN TO CA TO CAUSE CANCER.
TARG ET ORGANS:FLUX FUMES:EYES, MUC MEMBS & RESP SYS. INGEST OF
LEAD METAL CAN EFT KIDNEYS, GI, REPRO & NEUROLOGICAL SYSTEMS.
================== Physical/Chemical Properties ==================
Spec Gravity:>1 (H*2O=1@25C)
Evaporation Rate & Reference:<0.1 (BUTYL ACETATE=1)
Solubility in Water:(% BY WT):<5
Appearance and Odor:GRAY METALLIC PASTE WITH MILD ODOR.
Percent Volatiles by Volume:0.2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:WHEN HEATED TO SOLDERING TEMPS, SOLVS
ARE EVAP & THERMAL DEGRADATION PRODS MAY INCLUDE ALIPHATIC
ALDEHYDES, (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . SOLDERPASTE CAN BE MELTED TO RECLAIM THE SOLDER
METAL. CONTAINERS AND EXTRACTED FLUX ARE HAZARDOUS WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2118 FILLER REMOVER
CAGE:FO883
CAGE:FO883
CAGE:76708
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *95-2*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 55%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DIACETONE ALCOHOL
CAS:123-42-2
RTECS #:SA9100000
Fraction by Wt: 15%
Other REC Limits:50 PPM
OSHA PEL:240 MG/CUM
ACGIH TLV:238 MG/CUM
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 30%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOL ORGANIC CMPD: 867.60 G/L; 7.23 LB/GAL.
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: ANESTHETIC. IRRITATION OF
THE RESPIRATORY TRACT/NERVOUS SYSTEM DEPRESSION. SKIN/EYES: PRIMARY
IRRITATION. OVEREXPOSURE BY INHALATION/SKIN ABSORPTION MAY CAUSE
KIDNEY, LIVER & BLOOD DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, STAGGERING
GAIT, CONFUSION, UNCONSCIOUSNESS, COMA
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM & QUIET. EYES: IMMEDIATELY FLUSH W/COPIOUS QUANTITIES OF
RUNNING WATER FOR 15 MINS. SKIN: REMOVE W/SOAP & WATER. INGESTION:
DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:0F
Lower Limits:1
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE
USED TO COOL CLOSED CONTAINERS WHEN EXPOSED TO EXTREME HEAT. IF
WATER IS USED, FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. ISOLATE FROM HEAT/IGNITION SOURCES. DON'T
APPLY TO HOT SURFACES. FLAMMABLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. AVOID BREATHING
VAPORS. VENTILATE AREA. REMOVE W/INERT ABSORBENT & NON-SPARKING
TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED FOR STORAGE OF FLAMMABLE LIQUIDS.
CONTAINERS SHOULD BE GROUNDED WHEN POURING.
Other Precautions:AVOID FREE FALL OF LIQUIDS IN EXCESS OF A FEW INCHES.
DON'T FLAME CUT, BRAZE/WELD W/OUT MSHA/NIOSH APPROVED
RESPIRATOR/APPROPRIATE VENTILATION. DON'T TAKE INTERNALLY. PREVENT
PROLONGED SKIN CONTACT W/ CONTAMINATED CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VAPOR CONCENTRATION EXCEEDS THE TLV, USE
NIOSH APPROVED RESPIRATOR W/ORGANIC CHEMICAL CARTRIDGE.
Ventilation:PROVIDE GENERAL DILUTION/LOCAL EXHAUST VENTILATION IN
VOLUME & PATTERN TO KEEP TLV BELOW ACCEPTABLE LIMIT.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH W/SOAP & WATER BEFORE EATING, SMOKING/USING TOILET
FACILITIES.
Supplemental Safety and Health
FLASHPOINT IS FAR ACETONE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:137-336F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, ELECTRICAL
EQUIPMENT, STATIC/FRICTIONAL SPARKS, HOT SURFACES & OTHER IGNITION
SOURCES
Hazardous Decomposition Products:CO, OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T INCINERATE CLOSED CONTAINERS. DISPOSE OF
IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KAPTON FN
CAGE:EO716
CAGE:18873
CAGE:EO716
============= Composition/Information on Ingredients =============
Ingred Name:ACETAMIDE, N,N-DIMETHYL-; (DIMETHYL ACETAMIDE)
CAS:127-19-5
RTECS #:AB7700000
Fraction by Wt: <1%
OSHA PEL:10 PPM, S
ACGIH TLV:10 PPM, S
Ingred Name:POLYIMIDE POLYMER
CAS:25038-81-7
Other REC Limits:10 MG/M3 (MFR)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPP DATA:USED AS PROTECTIVE PACKAGING FOR "KAPTON".
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:FOR FILM. THOUGH "KAPTON" IS NOT HEATED TO
DEGRADATION TEMPS DURING NORMAL USE, HEATING "KAPTON" (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:FLUOROCARBON COATINGS TO TEMPS >350C CAN PRDCE TRACE
AMTS OF TOX & IRRIT GASES/VAPS OF HYDROGEN FLUORIDE, (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:CARBONYL FLUORIDE & POSSIBLY PERFLUOROISOBUTYLENE.
THESE CMPDS CAN CAUSE SEV EYE, SKIN & RESP TRACT (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:IRRITATION. INHALATION CAN CAUSE SHORTNESS OF BREATH
& OTHER RESPIRATORY EFFECTS & SYMPTOMS MAY BE DELAYED.
RTECS #:9999999ZZ
Ingred Name:VENT:NORMAL AIR CIRCULATION MAY BE ALL THAT IS NEEDED IN
CASE OF OVERHEATING. WHETHER/NOT EXISTING VENT IS ADEQ (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:AT HIGHER TEMPERATURES WILL DEPEND ON COMBINED
FACTORS OF FILM QUANTITY, TEMPERATURE & EXPOSURE TIME.
RTECS #:9999999ZZ
Ingred Name:INERT POLYIMIDE FILM (COATED OR LAMINATED W/ING 2 OR ING 3
OR ING 4)
RTECS #:9999999ZZ
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TEFLON FEP; (POLYFLUOROCARBON)
CAS:25067-11-2
Other REC Limits:10 MG/M3 (MFR)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FLUORINATED ETHYLENE PERFLUOROALKYL VINYL ETHER COPOLYMER,;
(POLYFLUOROCARBON)
CAS:26655-00-5
Other REC Limits:10 MG/M3 (MFR)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYFLUOROCARBON
CAS:68258-85-5
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:NOT PROBABLE RTE OF EXPOS FOR
FILM. FOR POLYMER FROM WHICH FILM IS MADE, DUPONT RECS TREATING
POLYMER DUST AS NUISANCE PARTICULATE. VAPS & FUMES FROM HEATING
"KAPTON" FLUOROCARBON COATINGS >275C , OR FROM SMOKING
TOBACCO/CIGARETTES CONTAM W/FLUOROCARBON COATINGS MAY CAUSE POLYMER
FUME FEVER, A (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:TEMPORARY, FLU-LIKE ILLNESS OF APPROX
24 HRS DURATION W/FEVER, CHILLS & SOMETIMES COUGH. SKIN CONT:NO
IRRIT IS EXPECTED FROM HNDLG FILM. <1 PPM DIMETHYL ACETAMIDE WAS
EXTRACTED FROM FILM BY D ISTILLED WATER AT 40C FOR 4 HRS. EYE
CONT:NOT PROBABLE RTE OF EXPOS FOR FILM. INGEST:NOT PROBABLE RTE OF
EXPOS (ING 8)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:MOVE TO FRESH AIR. CONSULT
MD IF SYMPTOMS PERSIST. SKIN:WASH W/SOAP & WATER AFTER HANDLING. IF
IRRITATION DEVELOPS, CONSULT MD. EYES:FLUSH W/PLENTY OF WATER FO R
AT LEAST 15 MINUTES. CONSULT MD IF SYMPTOMS PERSIST.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:FLAMMABILITY CHARACT OF POLYIMIDE FILM IS
REPORTED AS "SELF-EXTING". "KAPTON" CHARS BUT DOES NOT BURN IN AIR.
COATED TYPES OF "KAPTON" WILL BURN IN ATM (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:NOTE:REVIEW FIRE FIGHTING MEASURES & HANDLING
(PERSONNEL) SECTIONS BEFORE PROCEEDING W/CLEAN-UP. USE APPROPRIATE
PERSONAL PROTECTIVE EQUIPMENT DURING CLEAN-UP. PICK UP TO PREVENT
SLIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTAMINATION OF TOBACCO
PRODUCTS. STORE AWAY FROM FLAMM MATLS. BEFORE USING "KAPTON"
POLYIMIDE FILMS, READ BULLETIN ON SAFE HANDLING & USE.
Other Precautions:MEDICAL USE:CAUTION:DO NOT USE IN MEDICAL
APPLICATIONS INVOLVING PERMANENT IMPLANTATIONS IN HUMAN BODY. FOR
OTHER MEDICAL APPLICATIONS SEE DUPONT CAUTION BULLETIN NO. H-50102.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT REQUIRED FOR NORMAL PROCESSING.
Ventilation:SAFE HNDLG OF "KAPTON" POLYIMIDE FILMS AT HIGH TEMPS(>200C)
REQS ADEQ VENT. IF SM QTYS OF "KAPTON" ARE INVOLVED,(ING 12)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EXPLO HAZ:OF 95% OXYG WHEN IGNIT SOURCE IS PRESENT. COMBUST PRODS INCL
CARBON MONOXIDE, HYDROGEN FLUORIDE, CARBONYL FLUORIDE & POSSIBLY
PERFLUOROISOBUTYLENE. PROCESSING OF "KAPTON" POLYIMIDE FILMS CAN
CAUSE GENERATION OF STATIC CHARGE. PRECS FOR STATIC CHARGES SHOULD
ALSO BE TAKEN WHEN REMOVING PLASTIC FILMS (ING 7)
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:NONE
Spec Gravity:>1.4
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT AMBER TRANSPARENT FILM; NO ODOR.
Percent Volatiles by Volume:1 MAX
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
FLUOROCARBON COATINGS REACT W/FINELY DIVIDED METAL PWDRS & FLUORINE &
RELATED CMPDS (E.G. CHLORINE TRIFLUORIDE).
Stability Condition to Avoid:STABLE AT NORMAL TEMPERATURES & STORAGE
CONDITIONS.
Hazardous Decomposition Products:"KAPTON" FLUOROCARBON COATINGS MAY
DEGRADE AT TEMPERATURES >350C PRODUCING HYDROGEN FLUORIDE &
CARBONYL FLUORIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL OR INCINERATE IN COMPLIANCE W/FEDERAL,
STATE & LOCAL REGULATIONS. INCINERATOR SHOULD BE EQUIPPED
W/SCRUBBER TO REMOVE ACIDIC HYDROGEN FLUORIDE FROM OFF-GASES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:140-0977 DEAD FLAT BLACK - LACQUER
CAGE:54626
CAGE:54626
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE (DIMETHYLMETHANE)*98-2*
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:DICHLOROMETHANE (METHYLENE CHLORIDE) (SUSPECTED ANIMAL
CARCINOGEN IARC GROUP 2B & NTP) *98-1*
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 20%
OSHA PEL:500 PPM
ACGIH TLV:174 MG/CUM (A2)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SEC-BUTANOL ALCOHOL *98-1*
CAS:78-92-2
RTECS #:EO1750000
Fraction by Wt: <5%
Other REC Limits:100 PPM
OSHA PEL:150 PPM
ACGIH TLV:303 MG/CUM
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE *98-2*
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 20%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE, 2-BUTANONE *98-1*
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 10%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOBUTYL ACETATE
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: <5%
Other REC Limits:150 PPM
OSHA PEL:150 PPM
ACGIH TLV:713 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE, PROPANOIC ACID, 3-ETHOXY-, ETHYL
ESTER *98-1*
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: <5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:VAPORS MAY CAUSE ANESTHETIC EFFECTS,
UPPER RESPIRATORY/SKIN IRRITATION. OVEREXPOSURE TO SOLVENTS MAY
CAUSE PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION: LIGHTHEADEDNESS & STAGGERING GAIT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER
FOR 15 MINS. INGESTION: NEVER GIVE ANYTHING BY MOUTH IF
UNCONSCIOUS. DON 'T INDUCE VOMITING. GIVE SEVERAL GLASSES OF WATER.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<0
Lower Limits:0.7%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR PROTECTIVE EQUIPMENT INCLUDING SCBA.
WATER SPRAY MAY BE INEFFECTIVE. FOG NOZZLES ARE PREFERABLE. USE
WATER TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT SURFACES REQUIRES
SPECIAL PRECAUTIONS. VAPORS WILL ACCUMULATE/IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. VENTILATE &
REMOVE W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:USE IN VENTILATED AREA. USE APPROVED
BONDING/GROUNDING PROCEDURES. CONTENTS UNDER PRESSURE. AVOID
BREATHING VAPOR/SPRAY MIST & CONTACT W/SKIN & EYES.
Other Precautions:DON'T PUNCTURE, INCINERATE, OR EXPOSE TO TEMPERATURES
ABOVE 120F. HEAT FROM SUNLIGHT, RADIATORS, STOVES, HOT WATER, &
OTHER HEAT SOURCES COULD CAUSE CONTAINER TO BURST. DON'T TAKE
INTERNALLY. KEEP OUT OF REACH OF CHILDREN. DON'T SMOKE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR RESPIRATORY DEVICE APPROVED BY NIOSH/MSHA
FOR PROTECTION AGAINST INGREDIENTS LISTED AND WHEN PERSONAL
EXPOSURE CANNOT BE CONTROLLED BELOW APPLICABLE LIMITS.
Ventilation:LOCAL EXHAUST: PREFERRABLE, GENERAL EXHAUST: IF EXPOSURE TO
MATERIALS IS MAINTAINED BELOW EXPOSURE LIMITS
Supplemental Safety and Health
INTENTIONAL MISUSE BE DILIBERATELY CONCENTRATING & INHALING CONTENTS
CAN BE HARMFUL/FATAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0-325F
Vapor Density:>1
Evaporation Rate & Reference:FASTER THAN ETHER
Percent Volatiles by Volume:>75
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HOT WATER
Stability Condition to Avoid:HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN
FLAME, IGNITION SOURCES & SUNLIGHT.
Hazardous Decomposition Products:CO2, CO & HYDROGEN CHLORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PRODUCT MAY BE HAZARDOUS AS DEFINED
UNDER RCRA. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERMINE THE
APPLICABLE EPA HAZARDOUS WASTE NUMBERS. DON'T INCINERATE.
DEPRESSURIZE CONTAINER. DISP OSE OF IN ACCORDANCE W/FEDERAL, STATE,
& LOCAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KLINGER K-61
CAGE:9U500
CAGE:2G277
CAGE:9U500
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Fraction by Wt: >65%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:STYRENE POLYMER WITH 1,3-BUTADIENE
CAS:9003-55-8
RTECS #:WL6478000
Other REC Limits:NONE SPECIFIED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Other REC Limits:NONE SPECIFIED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:RUBBER
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:CHRONIC CONDITIONS SUCH AS PLEURAL
PLAQUE, ASBESTOSIS, LUNG CANCER AND MESOTHELIOMA MAY RESULT FROM
BREATHING FREE ASBESTOS FIBERS. INGESTION HAS BEEN WEEKLY LINKED TO
GASTROINTESTINAL CANCER. SKIN CO NTACT MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:CONTAINS A [1332-21-4] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:DIFFICULTY BREATHING, CHEAT PAIN, COUGHING, AND
FINGER CLUBBING OFTEN ACCOMPANY ASBESTOS-RELATED RESPIRATORY
DISEASES.
Medical Cond Aggravated by Exposure:INHALATION OF ASBESTOS FIBERS MAY
IRRITATE THE UPPER RESPIRATORY TRACT, MAY EXACERBATE PRE-EXISTING
CONDITIONS SUCH AS CHRONIC BRONCHITIS OR ASTHMA.
======================= First Aid Measures =======================
First Aid:INHALATION- REMOVE TO FRESH AIR, SEEK MEDICAL ATTENTION.
SKIN- FREQUENT WASHING WITH WATER WILL MINIMIZE IRRITATION AND
DETER TRANSITORY CHEMICAL OR MECHANICAL DERMATITIS. EYES- FLUSH
WITH WATER FOR 1 5 MINUTES, SEEK MEDICAL ATTENTION IF DISCOMFORT
PERSISTS. INGESTION- INDUCE VOMITING. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CARBON DIOXIDE, DRY POWDER OR FOAM.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR SCBA FOR PROTECTION
AGAINST TOXIC DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:POWDER/CLOUDS OF RUBBER PARTICLES FINER
THAN 840 MICRONS MAY PRODUCE A WEAK EXPLOSION. PROVIDE EXTRA
COOLING TO PREVENT SPONTANEOUS REIGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:TREAT DUST AS FREE ASBESTOS. DO NOT DRY SWEEP
OR USE COMPRESSED AIR.
======================Handling and Storage ======================
Handling and Storage Precautions:WHERE DUST PRODUCING ACTIVITIES OCCUR,
LOCAL VENTILATION, RESPIRATORS, HEPA VACUUMS, AND WET METHODS
SHOULD BE USED TO ENSURE CONTAINMENT OF FIBERS.
Other Precautions:WHEN COMBINED SMOKING, THE RISK OF ASBESTOS - RELATED
DISEASE INCREASES UP TO 25 TIMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH-APPROVED RESPIRATOR IF PEL IS EXCEEDED.
Ventilation:LOCAL EXHAUST, MECHANICAL VENTILATION IF AIRBORNE LEVELS
EXCEED PEL.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:AVOID CREATING DUST. AVOID BREATHING DUST. USE
PERSONAL PROTECTION EQUIPMENT. PRACTICE GOOD HOUSEKEEPING. DO NOT
SMOKE.
Supplemental Safety and Health
CONTAINS ASBESTOS FIBERS; AVOID CREATING DUST. CANCER AND LUNG DISEASE
HAZARD.
================== Physical/Chemical Properties ==================
HCC:T6
Spec Gravity:1.75 G/CC
Solubility in Water:INSOLUBLE
Appearance and Odor:COMPOSITE MATERIAL COMES IN BLACK & OFF WHITE
SHEETS OF VARIOUS THICKNESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ACIDS AND BASES.
Hazardous Decomposition Products:POSIBLE PYROLYTIC PRODUCTS FROM
STYRENE BUTADIENE RUBBER & OTHER AROMATIC AND ALIPHATIC
HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:APPROVED LANDFILL IN ACCORDANCE WITH FEDERAL,
STATE, OR LOCAL LAWS AND ORDINANCES. INCINERATION IN SUITABLE
COMBUSTION CHAMBER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P35522B
CAGE:EO440
CAGE:0ABC8
CAGE:EO440
============= Composition/Information on Ingredients =============
Ingred Name:M-NITROBENZENESULFONIC ACID SODIUM SALT
RTECS #:BD7195000
Fraction by Wt: 100%
======================= First Aid Measures =======================
First Aid:WASH WITH WATER
===================== Fire Fighting Measures =====================
Flash Point:550F
Extinguishing Media:WATER
Fire Fighting Procedures:USE WATER ONLY
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AND PICK UP SOLIDS INTO CONTAINER,
SMALL AMOUNTS OF RESIDUE CAN BE WASHED IO SEWER SO THAT LESS THAN
2PPM WILL RESULT IN EFFLUENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STANDARD WAREHOUSE PRECAUTIONS, AVOID
TEMPERATURES OVER 500F.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHAUST RECOMMENDED
Supplemental Safety and Health
CAS# 127-68-F EPA# A226-0333. P.O. BOX 5857, GREENVILL, S.C. 29606.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NONE
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW TO TAN PARTICLES
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXDIZING AGENTS
Stability Condition to Avoid:AVOID TEMPERATURES OVER 500F.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNUSABLE MATERIAL CAN BE INCINERATED WITH
CAUTION AS IT IS A SELF OXIDIZER WHEN IGNITED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-944-F-NS, PART A
Kit Part:Y
Preparer's Name:SR
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:PHENOL,POLYMER WITH FORMALDEHYDE,GLYCIDYL ETHER
CAS:28064-14-4
Fraction by Wt: 15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHTHALIC ACID, DIBUTYL ESTER; (DIBUTYL PHTHALATE) (SARA
313) (CERCLA)
CAS:84-74-2
RTECS #:TI0875000
Fraction by Wt: 30%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, REDNESS & TEARING.
SKIN: IRRITATION. MAY CAUSE AN ALLERGIC REACTION IN SENSITIZED
INDIVIDUALS. INHAL: NASAL & RESPIRATORY TRACT IRRITATION. INGEST:
SEVERE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LUKE WARM WATER FOR AT LEAST 15 MINUTES. IF
SYMPTOMS PERSIST, CONSULT MD. SKIN: WASH W/SOAP & WATER. IF
SYMPTOMS PERSIST, CONSULT MD. INHAL: REMOVE TO FRESH AIR. IF
SYMPTOMS ARE PRESENT CONSULT MD. INGEST: CONSULT MD.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP INTO CONTAINERS. CLEAN-UP RESIDUE
W/1,1,1-TRICHLOROETHANE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL VENTILATION TO MAINTAIN VAPOR BELOW PEL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.48
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT A HAZARDOUS WASTE ACCORDING TO EPA
REGULATIONS. CONSULT LOCAL, STATE & FEDERAL REGULATIONS PRIOR TO
DISPOSAL OF SPILLAGE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SCOTTS FLOWER, ROSE, HERB BUILDER, 18-11-12
CAGE:DO909
CAGE:DO909
============= Composition/Information on Ingredients =============
Ingred Name:UREA
CAS:57-13-6
RTECS #:YR6250000
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM PHOSPHATE MONOBASIC
CAS:7722-76-1
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM CHLORIDE
CAS:7447-40-7
RTECS #:TS8050000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50:
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:POSSIBLE SKIN OR EYE IRRITATION.
POSSIBLE NAUSEA, VOMITING, DIARRHEA.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:MAY CAUSE EYE, SKIN IRRITATION. MAY ALSO CAUSE
HEADACHE, DIZZINESS AND NAUSEA. ASPIRATION PNEUMONITIS MAY CAUSE
COUGHING, LABORED BREATHING, CYANOSIS, AND IN SEVERE CASES, DEATH.
Medical Cond Aggravated by Exposure:NA
======================= First Aid Measures =======================
First Aid:INDUCE VOMITING OR GASTRIC LAVAGE IF LARGE AMOUNTS INGESTED.
TREAT SYMPTOMATIC AND SUPPORTIVE. WASH EXPOSED AREAS. IF IN EYES,
FLUSH WITH WATER FOR 15 MINUTES. IF IRRITATION PERSISTS, SEE
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:USE DRY CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP SPILLS. USE GOOD HOUSEKEEPING
PRACTICES.AVOID CONTACT WITH SKIN, EYES, OR CLOTHING. WASH AFTER
HANDLING.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NA
Ventilation:NA
Other Protective Equipment:NA
Work Hygienic Practices:NA
Supplemental Safety and Health
NA
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:NA
pH:NA
Evaporation Rate & Reference:NA
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRANULAR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NA
Stability Condition to Avoid:NA
Hazardous Decomposition Products:AMMONIA
==================== Disposal Considerations ====================
Waste Disposal Methods:REMOVE TO APPROVED LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BRITEMOR 668 FLUORESCENT PENETRANT
CAGE:82925
CAGE:82925
============= Composition/Information on Ingredients =============
Ingred Name:MANUFACTURER CLAIMS ONLY NON-HAZARDOUS INGREDIENTS W/O
SPECIFYING ANY INDIVIDUAL INGREDIENT.
Fraction by Wt: 100%
Other REC Limits:MFR 5 MG/M3 OIL MIST
===================== Hazards Identification =====================
LD50 LC50 Mixture:PRODUCT'S LD50 (ORAL RAT) WAS NOT STATED
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:LIQUID WILL IRRITATE EYES.
SKIN:PROLONGED &/OR REPEATED CONTACT MAY DEFAT SKIN CAUSING
IRRITATION & DERMATITIS. INHALATION:HIGH VAPOR CONCENTRATIONS MAY
CAUSE RESPIRATORY IRRITATION, DIZZINESS, WE AKNESS, FATIGUE,
NAUSEA, HEADACHE. INGESTION:MAY CAUSE G/I IRRITATION, NAUSEA,
VOMITING, DIARRHEA. ASPIRATION HAZARD!
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO INGREDIENTS
CURRENTLY ON OSHA OR IARC LISTS.
Effects of Overexposure:EYE:IRRITATION. SKIN:PROLONGED &/OR REPEATED
CONTACT;DEFATTING, IRRITATION & DERMATITIS. INHALATION:RESPIRATORY
IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE.
INGESTION:G/I IRRITATION, NA USEA, VOMITING, DIARRHEA. ASPIRATION
HAZARD!
Medical Cond Aggravated by Exposure:NO DATA AVAILABLE.
.
======================= First Aid Measures =======================
First Aid:IF IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL ATTENTION.
EYE:FLUSH W/WATER FOR 15 MIN. SKIN:WASH W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. INHALED:REMOVE FROM
EXPOSURE. I NGESTED:DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>212F,>100C
Lower Limits:0.6
Upper Limits:7
Extinguishing Media:USE FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WHEN
FIRE FIGHTING IN A CONFINED SPACE.
Unusual Fire/Explosion Hazard:COOL CONTAINERS EXPOSED TO INTENSE HEAT
W/WATER TO PREVENT PRESSURE BUILDUP & RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE & CONTAIN SPILL. RECOVER FREE LIQUID.
ABSORB REMAINDER ON INERT MATERIAL & PLACE IN PROPER CONTAINERS FOR
DISPOSAL. DO NOT ALLOW SPILL TO ENTER DRAINS, SEWERS OR WATERWAYS.
COMPLY W/ALL SPILL NOT IFICATIONS. RESPONSE MUST COMPLY W/HAZWOPER.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:GROUND CONTAINERS WHEN TRANSFERRING
LIQUID. PROTECT FROM STATIC ELECTRICAL SPARKS OR OTHER IGNITION
SOURCES. STORE AWAY FROM STRONG OXIDIZERS.
Other Precautions:CLEAN CONTAMINATED EQUIPMENT BEFORE STARTING REPAIR
WORK.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED W/NORMAL RECOMMENDED USE. HOWEVERR
IF CONDITIONS WARRANT, USE NIOSH/MSHA-APPROVED RESPIRATORY
PROTECTION. COMPLY W/29CFR1910.134.
Ventilation:USE FORCED VENTILATION TO MINIMIZE VAPOR/MIST
CONCENTRATIONS IN THE WORKPLACE.
Other Protective Equipment:WEAR FULL-COVER SHIRT & PANTS TO MINIMIZE
CONTACT. IF EXCESSIVE SPLASHING IS EXPECTED USE FACE SHIELD &
RUBBER APRON.
Work Hygienic Practices:AVOID EYE/SKIN CONTACT. AVOID BREATHING
VAPORS/MISTS. ALL USERS SHOULD CONSULT THIS MSDS BEFORE HANDLING
THIS MATERIAL.
Supplemental Safety and Health
PROVIDE LOCAL EMERGENCY SHOWER & EYE WASH STATIONS IN THE WORK PLACE.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:459F,237C
Vapor Pres:1 MM
Vapor Density:>1
Spec Gravity:0.98
Evaporation Rate & Reference:<1 BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW-GREEN LIQUID;CHARACTERISTEC ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STORE AWAY FROM STRONG OXIDIZERS.
Stability Condition to Avoid:MFR GAVE NO INFORMATION OF MSDS.
Hazardous Decomposition Products:HYDROCARBON DECOMPOSITION PRODUCTS AT
ELEVAATED TEMPERATURES.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS. RECYCLE WASTE WHERE APPLICABLE. .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ACETIC ANHYDRIDE
Resp. Party Other MSDS Num.:MSDS #A0338
Preparer's Name:STRATEGIC SERVICE DIV
CAGE:HO851
Contract Num:MDA414-01-P-1174
CAGE:59896
CAGE:HO851
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ANHYDRIDE
CAS:108-24-7
RTECS #:AK1925000
Minumum % Wt:97.
Maxumum % Wt:100.
OSHA PEL:20 MG/M3;5 PPM
ACGIH TLV:21 MG/M3;5 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50: 1780 MG/KG
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: VAPORS CORROSIVE TO MUCOUS
MEMBRANES OF UPPER RESPIRATORY TRACT. EXPOSURE TO VAPORS CAUSE
IRRITATION OF NOSE, THROAT, COUGHING. INGESTION: CORROSIVE. CAUSES
BURNING PAIN IN STOMACH, FOLLOW ED BY NAUSEA AND VOMITING. SKIN:
CORROSIVE: DOES NOT CAUSE SEVERE BURNING ON CONTACT BUT CAN CAUSE
DELAYED REACTION BURNS. IF NOT REMOVED BY WASHING, SKIN MAY REDDEN
AND LATER TURN WHITE, WRINKLED. CO NTINUED SKIN CONTACT MAY CAUSE
DERMATITIS. EYE: CORROSIVE: CONTACT WITH LIQUID OR VAPOR PRODUCE
BURNING SENSATION AND TEARING.
Explanation of Carcinogenicity:NOT A KNOWN OR AN ANTICIPATED
CARCINOGEN.
Effects of Overexposure:INHALATION: EXPOSURE TO HIGH CONCENTRATIONS
RESULT IN SEVERE DAMAGE TO LUNGS. SYMPTOMS OF LUNG EDEMA OFTEN
DELAYED AND AGGRAVATED BY PHYSICAL EFFORTNESS. EYE: PAIN AND
BLURRED VISION, PERMANENT EYE D AMAGE. APPEARANCE OF EYE BURNS MAY
BE DELAYED. IRRITATION EFFECTS BEGIN WITH AIRBORNE CONCENTRATIONS
AS LOW AS 0.36 MG/M3. REPEATED AND PROLONGED EXPOSURE TO VAPOR MAY
CAUSE IRRITATION OF THE SKIN AND CHRONIC EYE IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISITING SKIN
DISORDERS OR EYE PROBLEMS, OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THE SUBSTANCES.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. GET
MEDICAL ATTENTION IMMEDIATELY. INGESTION: IF SWALLOWED, DO NOT
INDUCE VOMITI NG. GIVE LARGE QUANTITIES OF WATER. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. GET MEDICAL ATTENTION
IMMEDIATELY. SKIN: IMMEDIATELY FLUSH SKIN WITH PLENTY OF WATER FOR
15 MINUTES.. REMOVE AND WASH CONTAMINATED CLOTHING AND SHOES
BEFORE REUSE. GET MEDICAL ATTENTION IMMEDIATELY. EYE: IMMEDIATELY
FLUSH EYES WITH PLENTY OF WATER FOR 15 MINUTES. LIFTING LOWER/UPPER
EYELIDS OCCASIONALLY. GET MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:=48.9C, 120.F
Autoignition Temp:=316.1C, 601.F
Lower Limits:2.7
Upper Limits:10.3
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, ALCOHOL FOAM, OR CARBON
DIOXIDE. USE WATER WITH CAUTION AS MATERIAL REACTS WITH WATER.
Fire Fighting Procedures:IN EVENT OF FIRE, WEAR FULL PROTECTIVE
CLOTHING AND NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH
FULL FACEPIECE OPERATED IN THE PRESSURE DEMAND OR OTHER POSITIVE
PRESSURE MODE. USE WATER SPR AY TO BLANKET FIRE, COOL FIRE EXPOSED
CONTAINERS TO FLUSH NON-IGNITED SPILLS OR VAPORS AWAY FROM FIRE.
Unusual Fire/Explosion Hazard:ABOVE FLASHPOINT, VAPOR-AIR MIXTURES ARE
EXPLOSIVE WITHIN FLAMMABLE LIMITS. SEALED CONTAINERS MAY RUPTURE
WHEN HEATED. VAPORS FLOW ALONG SURFACES TO IGNITION SOURCE AND
FLASH BACK. VIOLENT EXOTHERMIC REACTION OCCURS WITH WATER.
SUFFICIENT HEAT MAY PRODUCED TO IGNITE COMBUSTIBLE MATERIALS.
SENSITIVE TO STATIC DISCHARGE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF LEAK OR SPILL. WEAR PERSONAL
PROTECTIVE EQUIPMENT. ISOLATE HAZARD AREA. KEEP
UNNECESSARY/UNPROTECTED PERSONNEL FROM ENTERING. WATER SPRAY TO
DISPERSE VAPORS AND DILUTE SPILLS TO NONF LAMMABLE MIXTURES, BUT BE
AWARE OF POTENTIAL FOR VIOLENT REACTION WITH WATER. NEUTRALIZE WITH
SODA ASH OR LIME. CONTAIN AND RECOVER LIQUID. COLLECT LIQUID IN
CONTAINER OR ABSORB WITH INERT MATERIAL,
Neutralizing Agent:INERT MATERIALS: VERMICULITE, DRY SAND, EARTH.
NEUTRALIZING AGENT: SODA ASH.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE. STORE
IN COOL, DRY WELL-VENTILATED LOCATION, AWAY FROM ANY AREA WHERE
FIRE HAZARD MAY BE ACUTE. OUTSIDE OR DETACHED STORAGE IS PERFERRED.
SEPARATE FROM INCOMPATIBLES. CONTAINERS SHOULD BE BONDED AND
GROUNDED FOR TRANSFERS TO AVOID STATIC SPARKS. KEEP AWAY FROM
WATER.
Other Precautions:USE NON-SPARKING TYPE TOOLS AND EQUIPMENT, INCLUDING
EXPLOSION PROOF VENTILATION. MATERIAL IS CORROSIVE TO STEEL,
GALVANIZED IRON, COPPER, COPPER ALLOYS. CONTAINERS OF THIS MATERIAL
MAY BE HAZARDOUS WHEN EMPTY SINCE THEY RETAIN PRODUCT RESIDUES
(VAPORS, LIQUID); OBSERVE ALL WARNINGS AND PRECAUTIONS LISTED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE LIMIT IS EXCEEDED, FULL FACEPIECE
RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE MAY BE WORN UP TO 50 TIMES
EXPOSURE LIMIT OR MAXIMUM USE CONCENTRATION BY REGULATORY AGENCY
OR RESPIRATOR SUPPLIE R, WHICHEVER LOWEST. FOR EMERGENCIES OR
INSTANCES WHERE THE EXPOSURE LEVELS ARE NOT KNOWN, USE A
FULL-FACEPIECE POSITIVE-PRESSURE, AIR-SUPPLIED RESPIRATOR.
Ventilation:A SYSTEM OF LOCAL AND/OR GENERAL EXHAUST IS RECOMMENDED TO
KEEP EMPLOYEE EXPOSURES BELOW THE AIRBORNE EXPOSURE LIMITS.
PERSONAL PROTECTIVE EQUIPMENT
WHERE SPLASHING POSSIBLE.
Other Protective Equipment:WEAR IMPERVIOUS PROTECTIVE CLOTHING,
APPROPRIATE, TO PREVENT SKIN CONTACT. MAINTAIN EYE WASH FOUNTAIN
AND QUICK-DRENCH FACILITIES IN WORK AREA.
Supplemental Safety and Health
WARNING: AIR PURIFYING RESPIRATORS DO NOT PROTECT WORKERS IN
OXYGEN-DEFICIENT ATMOSPHERES. CAROLINA BIOLOGICAL PART # 84-1392
================== Physical/Chemical Properties ==================
HCC:F6
Boiling Pt:=140.C, 284.F
Melt/Freeze Pt:=-72.6C, -99.F
Vapor Pres:4@20C(68F)
Vapor Density:3.52
Spec Gravity:1.08@15C/4C
pH:NO INFORMATION
Evaporation Rate & Reference:(BUAC=1)0.46
Solubility in Water:SLOWLY SOLUBLE WATER
Appearance and Odor:CLEAR, COLORLESS LIQUID. ODOR: STRONG ACETIC ODOR;
GOOD WARNING.
Percent Volatiles by Volume:@21C(70F)100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, STEAM, MINERAL ACIDS, OXIDIZING MATERIALS, ALCOHOLS, OR AMINES
MAY CAUSE VIOLENT REACTION. CONTACT WITH STRONG CAUSTICS WILL CAUSE
VIOLENT REACTION AND SPATTERING. CORROSIVE TO COPPER, BRASS,
BRONZE, AND IRON.
Stability Condition to Avoid:STABLE UNDER ORDINARY CONDITIONS OF USE
AND STORAGE. HEAT WILL CONTRIBUTE TO INSTABILITY. HEAT, FLAMES,
IGNITION SOURCES, WATER AND INCOMPATIBLES.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION, IT EMITS
TOXIC FUMES SUCH AS ACETIC ACID AND CARBON MONOXIDE. REACTS
VIOLENTLY WITH WATER TO YIELD ACETIC ACID AND MUCH HEAT.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:KORAL RAT LD50= 1780 MG/KG; INHALATION RAT
LC50 = 1000 PPM/4 HR; SKIN RABBIT LD50 = 4 ML/KG; IRRITATION DATA:
SKIN RABBIT, OPEN DRAIZE, 10 MG/24 HR MILD; EYE RABBIT, OPEN DRAIZE
250 MICRO GRAMS SEVERE .
===================== Ecological Information =====================
Ecological:WHEN RELAEASE INTO THE SOIL, THIS MATERIAL IS EXPECTED TO
LEACH INTO GROUND. WHEN RELEASED INTO GROUNDWATER/ WATER, THIS
MATERIAL IS EXPECTED TO REACT AND FORM ACETIC ACID. THIS MATERIAL
NOT EXPECTED TO SIGNIFICANTLY BIOACCUMULATES. ENVIRONMENTAL
TOXICITY: NO INFORMATION FOUND.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHAT CANNOT BE SAVED, SEND TO A RCRA APPROVED
WASTE FACILITY. PROCESSING, USE OR CONTAMINATION OF PRODUCT MAY
CHANGE WASTE MANAGEMENT OPTIONS. STATE AND LOCAL DISPOSAL
REGULATIONS MAY DIFFER FROM FEDE RAL DISPOSAL REGULATIONS. DISPOSE
OF CONTAINER AND UNUSED CONTENTS IN ACCORDANCE WITH FEDERAL, STATE
AND LOCAL REQUIREMENTS.
=================== MSDS Transport Information ===================
Transport Information:PSN: ACETIC ANHYDRIDE, 8, 3, UN1715, II.
===================== Regulatory Information =====================
SARA Title III Information:SARA 302 RQ & TPQ= NONE. SARA 313 LIST, CHEM
CATG: NO. RCRA CERCLA RQ= 5000 LBS. SARA 311/312: ACUTE: YES;
CHRONIC= YES; FIRE = YES; PRESSURE =NO. REACTIVITY = YES
(PURE/LIQUID)
Federal Regulatory Information:TSCA 261.33, 8(D) = NO; TSCA 12(B)= NO.
State Regulatory Information:LISTED ON EC, JAPAN, AUSTRALIAN, CANADA
DSL LISTS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LACTOL SPIRITS
CAGE:IO438
CAGE:77416
CAGE:IO438
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA, LIGHT ALIPHATIC
CAS:64742-89-8
Other REC Limits:NONE SPECIFIED
Ingred Name:N-HEPTANE
CAS:142-82-5
RTECS #:MI7700000
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9293
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYLCYCLOHEXANE
CAS:108-87-2
RTECS #:GV6125000
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:400 PPM; 9293
Ingred Name:CYCLOHEXANE (SARA III)
CAS:110-82-7
RTECS #:GU6300000
Other REC Limits:NONE SPECIFIED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM, 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:OTHER COMPONENTS (C6-C8 PARAFFINS AND CYCLOPARAFFINS)
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYES:IRRITATION,TEARING,REDNESS
& SWELLING.SKIN:IRRITATION,REDNESS,BURNING,DRYING &
DAMAGE.INHALATION:MAY IRRITATE NOSE,THROAT.MAY CAUSE
HEADACHE,DROWSINESS,DIZZINESS & LOSS OF COORDINATION.INGE STION:MAY
CAUSE IRRITATION OF GI TRACT,DIZZINESS,DROWSINESS,FATIGUE &
DIARRHEA.ASPIRATION->LUNG DAMAGE.CHRONIC-UNKNOWN.
Effects of Overexposure:SEE HEALTH HAZARDS SECTION. NOTE TO PHYSICIAN:
INHALING HIGH CONCENTRATION MAY BE HARMFUL OR FATAL. INHALATION OF
TOLUENE MAY CAUSE LIVER, KIDNEY AND BRAIN DAMAGE.
Medical Cond Aggravated by Exposure:PREEXISTING HEART AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IN ALL CASES.INHALATION:REMOVE TO FRESH
AIR.GIVE CPR/OXYGEN IF NEEDED.EYES:FLUSH WITH WATER FOR 15 MINUTES
WHILE HOLDING EYELIDS OPEN.SKIN:REMOVE CONTAMINATED CLOTHING.WASH
SKIN WITH SOAP & WATER.INGESTION:DO NOT INDUCE VOMITING.ASPIRATION
HAZARD.NOTE TO PHYSICIAN:EPINEPHRINE & OTHER SYMPATHOMIMETIC DRUGS
MAY INITIATE CARDIAC ARRHYTHMIAS IN PERSONS EXPOSED TO THIS
MATERIAL.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=-6.5C, 20.F
Lower Limits:1
Upper Limits:7
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL. DO NOT POINT SOLID WATER STREAM DIRECTLY INTO BURNING
OIL.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING INCLUDING A
POSITIVE-PRESSURE NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS. USE WATER TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AND CONTAIN.REMOVE WITH VACUUM TRUCK OR
PUMP TO STORAGE SALVAGE VESSELS.SOAK UP RESIDUE WITH AN ABSORBENT
SUCH AS CLAY,SAND OR OTHER SUITABLE MATERIALS.FLUSH AREA WITH WATER
TO REMOVE TRACE RESID UE.TAKE UP SMALL SPILLS WITH AN ABSORBENT
MATERIAL
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-STORE IN A COOL,WELL
VENTILATED AREA AWAY FROM FLAMES & SOURCES OF IGNITION.
Other Precautions:DO NOT BREATHE MIST.AVOID PROLONGED OR REPEATED
BREATHING OF VAPOR.AVOID CONTACT WITH EYES AND SKIN. WASH HANDS
BEFORE EATING OR DRINKING.DISCARD CONTAMINATED LEATHER ARTICLES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF AIRBORNE CONCENTRATIONS EXCEED ESTABLISHED
LIMITS, USE A SUPPLIED AIR RESPIRATOR. DO NOT USE A CHEMICAL
CARTRIDGE RESPIRATOR.
Ventilation:MECHANICAL VENTILATION (EXPLOSION PROOF)
Other Protective Equipment:EYE WASH STATION.LONG SLEEVE CLOTHING TO
MINIMIZE SKIN CONTACT.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
EMPTY CONTAINER RETAINS RESIDUE AND CAN BE DANGEROUS. DO NOT
PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL, GRIND OR EXPOSE TO
FLAMES, SPARKS OR HEAT; THEY MAY EXPLODE AND CAUSE INJURY OR DEATH.
================== Physical/Chemical Properties ==================
HCC:F2
NRC/State Lic Num:NOT RELEVANT
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID. TYPICAL HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, STRONG BASES AND
SELECTED AMINES.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME
Hazardous Decomposition Products:MAY YIELD CARBON MONOXIDE AND/OR
CARBON DIOXIDE. DO NOT BREATHE SMOKE OR FUMES. WEAR APPROPRIATE
PROTECTIVE EQUIPMENT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. EXTREMELY
FLAMMABLE. KEEP ALL SOURCES OF IGNITION AWAY. STAY UPWIND. WEAR
APPROPRIATE PROTECTIV E EQUIPMENT INCLUDING RESPIRATORY
PROTECTIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:309LHISIL STAINLESS STEEL BARE WELDING WIRE
Preparer's Name:JAN WALLACE
CAGE:FO309
CAGE:FO309
CAGE:27911
============= Composition/Information on Ingredients =============
Ingred Name:CARBON, GRAPHITE
ING: 0.03-0.12
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: ABOVE
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 23-25%
OSHA PEL:1 MG/CUM (CEILING)
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SOLUBLE) (SUSPECTED HUMAN CARCINOGEN BY NTP, IARC,
ACGIH) INTENDED CHANGE (IC)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 12-14%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC (A1)
Ingred Name:MOLYBDENUM (SOLUBLE COMPOUND), LEAD MOLYBDATE
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 0.75%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:MANGANESE, MN COMPOUNDS
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1-2.5%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:AMORPHOUS FUSED SILICA, SILICON DIOXIDE, QUARTZ, SILICON
INTENTED CHANGE (IC)
CAS:60676-86-0
RTECS #:VV7328000
Fraction by Wt: 0.30-1%
Other REC Limits:30 MG/CUM TOTAL DUST
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:COPPER (DUST & MIST), BRONZE POWDER
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0.75%
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: BALANCE
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: DISCOMFORT, DIZZINESS,
NAUSEA, DRYNESS OR IRRITATION OF THE THROAT.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION: PULMONARY IRRITATION OR
PNEUMOCONIOSIS & SIDEROSIS.
===================== Fire Fighting Measures =====================
Unusual Fire/Explosion Hazard:NONFLAMMABLE. WELDING ARC, OPEN FLAME &
SPARKS CAN IGNITE COMBUSTIBLES.
======================Handling and Storage ======================
Handling and Storage Precautions:TRAIN THE EMPLOYEE TO KEEP HIS HEAD
OUT OF THE FUMES & NOT TO TOUCH THE ELECTRICAL PARTS & TO INSULATE
HIMSELF FROM WORK & GROUND.
Other Precautions:TAKE AN AIR SAMPLE FROM INSIDE THE WELDER'S HELMET IF
WORN OR IN THE WORKER'S BREATHING ZONE TO DETERMINE THE COMPOSITION
& QUANTITY OF FUMES & GASES WHICH WORKERS ARE EXPOSED. AVOID INJURY
FROM RADIA TION/SPARKS/FLAME/ELECTRICAL SHOCK.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN WELDING, BRAZING OR SOLERING IN CONFINED SPACE OR
WHERE LOCAL EXHAUST OR VENTILATION DOES NOT KEEP <TLV.
Ventilation:LOCAL EXHAUST
SHOULDER PROTECTIVE & DARK SUBSTANTIAL CLOTHING.
Work Hygienic Practices:READ & UNDERSTAND THE MANUFACTURER'S
INSTRUCTIONS & PRECAUTIONARY LABEL ON THE PRODUCT.
Supplemental Safety and Health
WELDING ELECTRODE OR WIRE IS A NONHAZARDOUS SOLID AT AMBIENT
TEMPERATURE. HAZARDS MAY RESULT FROM FUME GENERATED DURING WELDING.
================== Physical/Chemical Properties ==================
Appearance and Odor:BARE WIRE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO2, OZONE, OXIDES OF METAL &
NITROGEN.
| 1 | gloves_mandatory |
=======================================================
Product ID: HERCULES PURPLE PVC PRIMER
Cage: 84794
=======================================================
Contractor Summary
=======================================================
Cage: 84794
=======================================================
Ingredients
=======================================================
Cas: 109-99-9
RTECS #: LU5950000
OSHA PEL: 200 PPM
ACGIH TLV: 200 PPM/250 STEL
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 78-93-3
RTECS #: EL6475000
% Wt: 85
OSHA PEL: 200 PPM
ACGIH TLV: 200 PPM/300 STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 108-94-1
RTECS #: GW1050000
OSHA PEL: S, 50 PPM
ACGIH TLV: S, 25 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:CORROSIVE TO EYES AND SKIN IRRITANT. SEVERE
OVEREXPOSURE CAN CAUSE HEADACHE, DIZZINESS & NARCOSIS. MAY CAUSE
DERMATOSIS & DERMATITIS WITH PRLNGD RPTD CONTACT. SIGNS & SYMPS OF
EXPOSURE:INHALATIO N:WILL CAUSE IRRITATION OF MUCOUS MEMBRANES, NOSE, EYES,
& THROAT, COUGHING, DIFFICULTY OF BREATHING. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:EXPOSURE TO HIGH VAPOR
CONCENTRATION MAY CAUSE HEADACHE, DIZZINESS, NAUSEA, NARCOSIS. SKIN
CONT:PROLONGED SKIN CONTACT CAUSES COMMON SOLVENT DEFATTING EFFECT. EYE
CONT:VAPORS SLIGHTLY UNCOMFO RTABLE. SPLASHES IRRITATING. WILL CAUSEPAINFUL
BURNING OR STINGING OF EYES & LIDS, WATERING OF EYES & CONJUNCTIVA.
Medical Cond Aggravated By Exposure: NO DATA FOUND.
First Aid: INGEST:DO NOT INDUCE VOMITING. IF CONSCIOUS, DILUTE BY GIVING 2
GLASSES OF WATER. CALL PHYS IMMED. INHAL:REMOVE TO FRESH AIR. IF NOT
BREATHING, GIVE ARTF RESP, PREFERABLY MOUTH-TO-MOUTH. IF BREATHING IS
DIFFICULT, GIVE OXYG. CALL PHYS. SKIN CONT:WASH AFFECTED AREA W/SOAPY WATER.
REMOVE CONTAMD CLOTHING. EYE CONT:IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST
15 MINUTES. CONSULT PHYS.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ELIMINATE SOURCES OF IGNITION. ABSORB WITH SAND OR
INERT ABSORBING MATERIAL. DISPOSE OF WITH SOLID WASTE IN ACCORDANCE WITH ALL
REGULATIONS. FLUSH SPILL AREA WITH WATER. AVOID FLUSHING INTO CONFINED A
REAS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: INCINERATE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
Handling And Storage Precautions: STORE IN COOL, WELL-VENTILATED AREA. KEEP
AWAY FROM OPEN FLAME AND SOURCES OF IGNITION.
Other Precautions: USE NORMAL GOOD PERSONAL HYGIENE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 6F,-14C
Lower Limits: 2%
Upper Limits: 11.8%
Extinguishing Media: FOAM/DRY CHEMICAL/CO*2.
Fire Fighting Procedures: NIOSH APPRVD SCBA & FULL PROTECTIVE EQUIP (FP N).
HANDLE AS FLAMMABLE LIQUID. WATER MAY BE INEFFECTIVE, BUT SHOULD BE USED TO
KEEP FIRE-EXPOSED CNTNRS COOL.
Unusual Fire/Explosion Hazard: VAP IS HVR/AIR & TRAVELS CONSIDERABLE DIST
TO SOURCES OF IGNIT & FLASHBACK. ON LONG STANDING MAY CAUSE PEROXIDES
WHICH MAY CAUSE VIOLENT RXN ESPECIALLY (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: IN CONFINED SPACES OR OTHER CIRCUMSTANCES WHERE
ADEQUATE VENTILATION CANNOT BE ASSURED USE NIOSH-APPRVD RESPIRATOR, NIOSH
APPRVD POSITIVE PRESSURE AIRLINE MASK, OR NIOSH APPRVD SELF CONTAINED
BREATHIN G APPARATUS.
Ventilation: LOCAL EXHAUST:AS REQUIRED.
Other Protective Equipment: APRON, BOOTS. ANSI APPRVD EYE WASH & DELUGE SHOWER
(FP N).
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: EXPLO HAZ:UPON EVAPORATION TO DRYNESS. EYE
PROT:& FULL LENGTH FACESHIELD (FP N).
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 151F,66C
Vapor Pres: 70
Vapor Density: 3
Spec Gravity: 0.827
Evaporation Rate & Reference: 5
Solubility in Water: 35%
Appearance and Odor: PURPLE LIQUID, ETHEREAL & ACETONE-LIKE ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: KEEP IN CLOSED CONTAINERS AWAY FROM SPARKS & OPEN
FLAME.
Materials To Avoid: STRONG OXIDIZING MATLS, LITHIUM ALUMINUM HYDRIDE, SODIUM
ALUMINUM HYDROXIDE, SODIUM & POTASSIUM HYDROXIDES.
Hazardous Decomposition Products: CARBON DIOXIDE & CARBON MONOXIDE ARE FORMED
IRRITATING PEROXIDE FUMES ARE FORMED WHEN HEATED TO DECOMPOSITION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: AVOID EXCESSIVE EXPOSURE TO AIR AND CATONIC
INITIATORS LIKE LEWIS ACIDS.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: HERCULES PURPLE PVC PRIMER
Cage: 84794
Company Name: HERCULES CHEMICAL CO INC
Street: 111 SOUTH STREET(OLD IS 29 W 38 ST)
Zipcode: 07055-7398
Label Required IND: Y
Date Of Label Review: 01/14/1997
Status Code: C
Label Date: 01/14/1997
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: EXTREMELY FLAMMABLE. ACUTE:CORROSIVE TO EYES & SKIN
IRRITANT. SEVERE OVEREXP CAN CAUSE HEADACHE, DIZZINESS & NARCOSIS. MAY
CAUSE DERMATOSIS & DERMATITIS W/PRLNGD RPTD CONTACT. SIGNS & SYMPS OF
EXPOSUR E:INHALATION:WILL CAUSE IRRITATION OF MUCOUS MEMBRANES, NOSE, EYES,
& THROAT, COUGHING, DIFFICULTY OF BREATHING. EXPOSURE TO HIGH VAPOR
CONCENTRATION MAY CAUSE HEADACHE, DIZZINESS, NAUSEA, NARCOSIS. S KIN
CONT:PROLONGED SKIN CONT CAUSES COMMON SOLVENT DEFATTING EFFECT. EYE
CONT:VAPORS SLIGHTLY UNCOMFORTABLE. SPLASHES IRRITATING. WILL CAUSE PAINFUL
BURNING/STINGING OF EYES & LIDS, WATERING OF EYES & CONJUNCTIVA.
CHRONIC:NONE LISTED BY MANUFACTURER
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A-106 ADHESIVE COMPONENT C
CAGE:HO030
CAGE:58149
CAGE:HO030
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 50%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DIBUTYLTINDI-2 ETHYL HEXOATE
CAS:2781-10-4
RTECS #:WH6714500
Fraction by Wt: 50%
ACGIH TLV:S,0.1MG/CUM SN
===================== Hazards Identification =====================
Effects of Overexposure:INHAL: SLIGHT ANESTHESIA, HDACH. SKIN: BURNS.
EYE: BURNS
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR, OBTAIN MD ATTENTION. SKIN: FLUSH
W/ WATER. EYE: FLUSH W/ WATER FOR 15 MIN.
===================== Fire Fighting Measures =====================
Flash Point:85F,25C,(CC)
Extinguishing Media:CO*2 OR FOAM
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:MOP, WIPE OR SOAK UP W/ ABSORBENT MATERIALS
USING PROPER PROTECTIVE EQUIPT.
======================Handling and Storage ======================
Handling and Storage Precautions:USE CARE FOR FLAM PRODUCT. AVOID SKIN
& EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MFR RECOMND NIOSH/MSHA APPRVD ORGANIC VAPOR
TYPE.
Ventilation:GENERAL-RECOMND TO MAINTAIN BELOW TLV
Supplemental Safety and Health
SP GRAVITY IS AN APPROX VALUE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:290F;143C
Vapor Pres:10
Spec Gravity:0.9
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:>10
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Hazardous Decomposition Products:TIN PROD, SIO*2 CO*2, & TRACES OF
UNBURNED CARBON CMPDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECOMMENDS RESIDUE FROM EVAPORATED SOLVENT
TO BE LANDFILLED OR BURNED. DISPOSAL MUST BE IAW FEDERAL, STATE &
LOCAL CODES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TITANIUM IN H*2O 10,000 UG/ML, I22815
CAGE:0L438
CAGE:0L438
============= Composition/Information on Ingredients =============
Ingred Name:TITANATE (2-), HEXAFLUORORO-, DIAMMONIUM;(AMMONIUM
HEXAFLUOROTITANATE)(MFR CAS NO 7550-45-0)
CAS:16962-40-6
RTECS #:XR1500000
Fraction by Wt: 0.1-1%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 99%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:NOT APPLICABLE. CHRONIC:NOT
APPLICABLE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:BURNS, COUGHING, IRRITATION, NAUSEA, VOMITING,
LABORED BREATHING.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN:FLUSH WITH
COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. WASH CONTAMINATED
CLOTHING BEFORE RE-USE. INHAL:REMOVE TO FRESH AIR. INGEST:DO NOT
INDUC E VOMITING.GIVE COPIOUS AMOUNTS OF WATER OR MILK.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED POSITIVE PRESSURE SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP WITH INERT, ABSORBENT MATERIAL.
CONTAINERIZE FOR DISPOSAL. FLUSH SPILL AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A CORROSION FREE AREA. KEEP
CONTAINER SEALED.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:LAB COAT OR APRON. EMERGENCY EYE WASH AND
DELUGE SHOWER .
Work Hygienic Practices:USUAL
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1 (H*2O=1)
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS, ODORLESS SOLUTION.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES OR STRONG REDUCING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT OR COLD.
==================== Disposal Considerations ====================
Waste Disposal Methods:CORROSIVE WASTE. DISPOSE OF IN ACCORDANCE WITH
ALL FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:51P88 MICARTA PAPER-PHENOLIC COMPOSITE
CAGE:76425
CAGE:1BY60
CAGE:76425
============= Composition/Information on Ingredients =============
Ingred Name:PHENOLIC RESIN
Ingred Name:CELLULOSE
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. INHALATION: NOSE,
THROAT & LUNG IRRITATION.
Explanation of Carcinogenicity:NONE
Medical Cond Aggravated by Exposure:PULMONARY PROBLEMS
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER, CO2, FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DUST FROM DRY FABRICATION MAY BE
EXPLOSIVE IF MIXED W/AIR IN CRITICAL PROPORTIONS & IN PRESENCE OF
AN IGNITION SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL FOR SOLID MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T ATTEMPT TO BREAK UNLESS EYES ARE
PROTECTED FROM POSSIBLE FLYING SPLINTERS/PARTICLES.
Other Precautions:WET SWEEPING WILL MINIMIZE DUST GENERATION. MAINTAIN
GOOD HOUSEKEEPING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED PARTICULATE RESPIRATORS
TC-21C SERIES IF PEL IS EXCEEDED.
Ventilation:USE DUST COLLECTOR FOR SAWING OR MACHINING.
Work Hygienic Practices:MAINTAIN GOOD HOUSEKEEPING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NONE
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID SHEETS, MOLDED SHAPES, W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, BASES
Stability Condition to Avoid:HEATING >450F.
Hazardous Decomposition Products:SMALL QUANTITIES OF HYDROGEN CYANIDE,
CO, & CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3812S ENAMEL REDUCERS
Preparer's Name:T R LOUER
CAGE:90227
CAGE:90227
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *95-4*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 50%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE
CAS:64742-89-8
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE & THROAT IRRITATION.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. SKIN: IRRITATION W/DERMATITIS. EYES:
IRRITATION & BURNING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, BURNING, DISCOMFORT.
EYE WATERING, HEADACHES, NAUSEA, DIZZINESS & LOSS OF COORDINATION
ARE SIGNS THAT SOLVENTS ARE TOO HIGH.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH W/SOAP & WATER.
EYES: WASH W/PLENTY OF WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:<73F
Lower Limits:0.6
Upper Limits:13.1
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:WHEN HEATED >FLASH POINT, EMITS FLAMMABLE
VAPORS WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLOSIVE. FINE
MISTS/SPRAYS MAY BE FLAMMABLE AT TEMP 120F.
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/OUT A
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. DON'T
BREATHE VAPORS/MISTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A PROPERLY FITTED VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA FOR USE W/PAINTS DURING
APPLICATION. CONFINED AREAS: USE POSITIVE PRESSURE, SUPPLIED AIR
RESPIRATOR. DON'T PERMIT ANYONE W/O PROTECTION IN PAINTING AREA.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:NEOPRENE COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
%VOLATILE BY VOLUME: 99.6-100.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:129-473F
Vapor Density:>1
VOC Grams/Liter:6.7
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:(SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME
Hazardous Decomposition Products:CO, CO2, SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. INCINERATE ABSORBED MATERIAL IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE IN CLOSED CONTAINERS. FLAMMABLE
LIQUID UN1263.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LACRYL L-205-T THINNER, L205
CAGE:87354
CAGE:87354
============= Composition/Information on Ingredients =============
Ingred Name:ING 13:CONSIDERED BY STATE OF CALIFORNIA TO CAUSE
CANCER/BIRTH DEFECTS/OTHER REPRO HARM.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:KEEP OUT OF DRAINS, SEWERS/WATERWAYS. CONT FIRE
AUTH. NOTIFY LOC HLTH & POLLUTION CONTROL AGENCIES. (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:CALL SPILL RESPONSE TEAMS IF LARGE SPILL.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:W/PROD SHOULD BE AVOIDED. SHOULD CONT BE MADE,
REMOVE SATURATED CLTHG & FLUSH AFFECTED SKIN AREAS W/ (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:H*2O. CNTNRS OF THIS MATL MAY BE HAZ WHEN EMPTIED.
SINCE EMPTIED CNTNRS RETAIN PROD RESIDUES (VAP, LIQ, (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:&/OR SOLID), ALL HAZ PRECS GIVEN IN THIS MSDS MUST
BE OBSERVED. DO NOT FLAME CUT/WELD EMPTY DRUMS.
RTECS #:9999999ZZ
Ingred Name:ING 12:SYS DMG. INTENT MISUSE BY DELIB CONC & INHAL
CONTENTS MAY BE HARMFUL/FATAL. PROD MAY CONTAIN CHEM(S) (INGRED 14)
RTECS #:9999999ZZ
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL). VP:0.60. LEL:1.1%.
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: <10%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:BUTYL ALCOHOL; (N-BUTANOL). VP:5.90. LEL:1.4%.
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: <25%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <10%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE. VP:6.60. LEL:1%.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <10%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL ALCOHOL. VP:40. LEL:3.5%.
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: <50%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:PARAFFIN SOLVENT (C6-C8)
Fraction by Wt: <25%
Ingred Name:C6-C8 CYCLOPARAFFINS
Fraction by Wt: <25%
Ingred Name:SUPP DATA:PRLNG OVEREXP/INGEST MAY CAUSE CNS
DEPRESS/DISORDER. INGS 3, 4, 6 & 7:DIRECT CONT W/EYES MAY CAUSE DMG
(ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:TO CONJUNCT & CORNEA IF NOT PROMPTLY REMOVED. INGS 1,
2, 3 & 6:INGEST WILL CAUSE IRRIT OF GI TRACT & MAY (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:CAUSE EFTS RESEMBLING THOSE FROM INHAL OF VAP. INGS 4
& 5:PULM EDEMA MAY DEVELOP W/INHAL OF HIGH CONCS OF (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:MATL:INGS 1, 2, 3 & 4:MAY CAUSE IRRIT, DRYING,
CRACKING/DERM ON PRLNG EXPOS TO SKIN. CAN BE ABSORBED THRU(ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:SKIN CAUSING ORGAN DMG. NOTICE:RPTS HAVE ASSOC RPTD
& PRLNG OCCUP OVEREXP TO SOLVS W/PERM BRAIN & NERV (ING 13)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SPRAY MIST/VAPS OF SPRAY PAINTS,
THINNERS & ADDITIVES MAY CAUSE IRRIT TO EYES, NOSE, THROAT, UPPER
RESP TRACT, MUC MEMBS & SKIN. ING 2:MOD TOX. SEV IRRIT TO EYES.
EXPOS MAY CAUSE EXTENSIVE CORNEAL INJ URY. ING 3:PRLNG OVEREXP MAY
CAUSE HDCH, NAUS, LOSS OF BALANCE, COORD & CONSCIOUSNESS, NARCOS,
COMA & (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:DEATH DUE TO RESP FAILURE. RPTD
EXCESSIVE EXPOS MAY ALSO CAUSE CHRONIC ADVERSE SYSTEMIC EFTS. ING
4:ASPIR CAN BE HAZ IF MATL IS SWALLOWED. MAY BE FATAL IF SWALLOWED.
ING 5:RPTD & PRLNG EXPOS MAY CAUSE DELAYED EFTS INVOLVING
BLOOD,GI, NERV & REPRO SYS. INGS 1 & 5:PRLNG OVEREXP TO VAPS MAY
CAUSE BLOOD (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/LUKE WARM H2O FOR @ LST 15 MINS. SEE MD IMMED.
SKIN:FLUSH WASH W/COPIOUS AMTS OF LUKE WARM H2O. REMOVE CONTAM
CLTHG PROMPTLY. CALL MD IMMED. INHAL:REMOVE EXPOSED PERS TO FRESH
AIR. RESTORE BRTHG IF REQD. CALL MD IMMED. INGEST:RINSE MOUTH
IMMED. GIVE EXPOSED PERS 6-8 OZS OF LIQ. (NEVER GIVE ANYTHING BY
MOUTH TO UNCON PERS.) DO NOT INDUCE VOMIT UNLESS ADVISED BY MD.
CALL MD IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:23.0F,-5.0C
Lower Limits:1%
Upper Limits:19%
Extinguishing Media:DRY CHEM, FOAM, CO2/ALCOHOL FOAM. H2O SPRAY MAY BE
USEFUL IN MINIMIZING VAPS & COOLING CNTNRS EXPOSED TO HEAT (SUPDAT)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD POSITIVE PRESSURE SCBA
& FULL PROT EQUIP . CLEAR FIRE AREA OF UNPROT PERS. FIGHT FIRE FROM
SAFE DIST OR PROTECTED LOCATION.
Unusual Fire/Explosion Hazard:LIQ & ITS VAPS ARE DANGEROUS FIRE HAZ &
MOD EXPLO HAZS WHEN EXPOSED TO HEAT, FLAME/ANY SOURCE OF IGNIT.
VAPS MAY BE HVR/AIR & MAY TRAVEL ALONG GROUND TO(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:STAY UPWIND & AWAY FROM SPILL UNLESS WEARING
APPROP PROT EQUIP. STOP &/OR CONTAIN DISCHARGE IF IT MAY BE DONE
SAFELY. KEEP ALL SOURCES OF IGNIT AWAY. VENT AREA OF SPILL. USE
NON-SPKING TOOLS FOR CLEAN UP. COVER W/INERT MATL TO REDUCE
FUMES.(ING 15)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PROD CNTNRS COOL, DRY & AWAY FROM
SOURCES OF IGNIT. USE & STORE PROD W/ADEQ VENT. ISOLATE FROM HEAT,
ELEC EQUIP, SPKS & OPEN FLAME.
Other Precautions:DO NOT SMOKE IN STOR AREAS. KEEP CNTNRS TIGHTLY CLSD
WHEN NOT IN USE. SPRINKLER FIRE PROT IS DESIRABLE IN AREA OF STOR,
HNDLG & USE. BOND & GROUND METAL CNTNRS WHEN TRANSFERRING LIQ. PERS
SHOULD AVOID INHAL OF VAPS/MIST. PERS CONT (ING 17)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROP, PROPERLY FITTED NIOSH/MSHA APPRVD
RESP DURING & AFT APPLICATN UNLESS AIR MONITORING DEMONSTRATES VAP
LEVELS ARE BELOW APPLIC LIMS. FOLLOW RESP MFR'S DIRECTIONS FOR RESP
USE.
Ventilation:USE VENT AS REQD TO CONTROL VAP CONC. IF EXPOS EXCEEDS TLV
USE NIOSH/MSHA APPRVD RESP TO PVNT OVEREXP.
Other Protective Equipment:EYEWASH STATIONS & SAFETY SHOWERS SHOULD BE
READILY AVAILABLE IN USE & HNDLG AREAS.
Work Hygienic Practices:WASH HANDS THORO BEFORE EATING & USING
WASHROOM. REMOVE CONTAM CLTHG IMMED & DO NOT REUSE UNTIL PROPERLY
LAUNDERED.
Supplemental Safety and Health
EXTING MEDIA:& FLAME. AVOID SPREADING BURNING LIQ W/H2O USED FOR
COOLING PURPOSES. EXPLO HAZ:DIST IGNIT SOURCE & FLASH BACK. KEEP
WELDING/CUTTING EQUIP AWAY FROM PROD. EFTS OF OVEREXP:
DISORDERS/DMG T O BLOOD FORMING ORGANS. INGS 1, 3, 5 & 6:CHRONIC
OVEREXP/ INGEST MAY CAUSE KIDNEY & LIVER INJURY. INGS 1, 4 & 5:
(ING 8
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:170F,77C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.762
Evaporation Rate & Reference:FASTER THAN BUTYL ACETATE
Appearance and Odor:CLEAR LIQUID, MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ORG SOLVS ARE INCOMPATIBLE W/STRONG OXIDIZERS; MAY CAUSE FIRE OR EXPLO
ON CONTACT.
Stability Condition to Avoid:AVOID EXPOS TO SPKS, OPEN FLAME, HOT
SURFACES & ALL SOURCES OF HEAT & IGNITION.
Hazardous Decomposition Products:IN PRESENCE OF AIR MAY FORM COX &
VARIOUS HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PRODUCT I/A/W APPLICABLE LOCAL,
COUNTY, STATE & FEDERAL REGULATIONS. DO NOT FLUSH TO SEWER,
WATERSHED OR WATERWAY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MYCOSTATIN TOPICAL POWDER
CAGE:BRIST
CAGE:BRIMY
CAGE:BRIST
============= Composition/Information on Ingredients =============
Ingred Name:NYSTATIN
CAS:1400-61-9
RTECS #:RF5950000
Fraction by Wt: 2.5%
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 97.5%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 10,000 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: PRODUCED ADVERSE GI
EFFECTS. INHALATION: NYSTATIN IS TOXIC AFTER SYSTEMIC INJECTION.
SKIN: TOXIC, PRODUCT MAY CAUSE IRRITATION IN SOME SENSITIVE
INDIVIDUALS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NAUSEA, VOMITING, GI DISTRESS, DIARRHEA,
IRRITATION.
Medical Cond Aggravated by Exposure:HYPERSENSITIVITY TO NYSTATIN.
======================= First Aid Measures =======================
First Aid:INGESTION: INDUCE VOMITING IF CONSCIOUS & NOT CONVULSING.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. INHALATION:
REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED. SKIN: WASH W/SOAP &
WATER. EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO2, FOAM/DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA, FLAME & CHEMICAL RESISTANT
UNNEEDED MATERIAL & COOL CONTAINERS W/WATER FROM A DISTANCE.
Unusual Fire/Explosion Hazard:FINE POWDERS ARE CONSIDERED TO BE
COMBUSTIBLES.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WIPE SOLIDS W/WET ABSORBENT GAUZE.
CLEAN USING DETERGENT & WATER. LARGE: COVER POWDER W/DAMP
CLOTH/TOWELS. CLEAN USING DETERGENTS & WATER. TREAT PRODUCT &
CONTAMINATED MATERIALS AS HAZARDOUS WA STE. INCINERATION IS
RECOMMENDED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMP. KEEP BOTTLE
TIGHTLY CLOSED. WHEN STORE IN ORIGINAL CONTAINER, DRUG IS STABLE TO
THE EXPIRATION DATE ON THE LABEL OF THE PRODUCT.
Other Precautions:AVOID EXCESSIVE HEAT. DON'T BREAK/SPILL BOTTLES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN CONTROLS AREN'T SUFFICIENT TO EXPOSURE,
WEAR NIOSH APPROVED RESPIRATORY PROTECTION APPROPRIATE FOR
EXPOSURE; SCBA SHOULD BE AVAILABLE FOR EMERGENCY USE.
Ventilation:LOCAL MECHANICAL EXHAUST RECOMMENDED TO MINIMIZE EXPOSURE.
GENERAL MECHANICAL MAY BE ADEQUATE FOR SOME OPERATIONS.
Other Protective Equipment:PROTECTIVE COVERALLS.
Work Hygienic Practices:WASH HANDS AFTER HANDLING COMPOUND & BEFORE
EATING, SMOKING, USING LAVATORY & AT THE END OF DAY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:YELLOWISH-WHITE POWDER SUPPLIED IN PLASTIC SQUEEZE
BOTTLES; PRACTICALLY ODORLES
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:ROOM TEMP, HEAT
Hazardous Decomposition Products:COMBUSTION: CO, CO2, NIRTOGEN OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TONER, SP-50B
CAGE:23736
CAGE:23736
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE ACRYLATE COPOLYMER
Fraction by Wt: >80%
Ingred Name:COPPER OXIDE
CAS:1317-38-0
RTECS #:GL7900000
Fraction by Wt: 5-10%
Ingred Name:ORGANIC PIGMENT
Fraction by Wt: 1-5%
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 1-5%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:PROPENE POLYMERS; (POLYPROPYLENE)
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: 1-3%
Ingred Name:TONER, AS A MIXTURE. LIMITS AS A NUISANCE DUST.
OSHA PEL:15 MG/M3;5 RESP
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50(ORAL,RAT) >5.0 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MINIMAL RESPIRATORY TRACT IRRIT
MAY OCCUR AS WITH EXPOS TO LRG AMTS OF ANY NONTOXIC DUST. MAY CAUSE
COUGH & RAISE PHLEGM. CHRONIC: NONE. TONER PRESENTS A LOW HAZ FOR
USUAL OCCUPATIONAL SETTINGS . BASED ON AVAIL DATA, HUMAN EXPOS TO
TONER HAS BEEN SHOWN TO CAUSE MINIMAL RESP TRACT IRRIT AS MAY(SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OCCUR W/LRG AMTS OF ANY NON-TOXIC
DUSTS. THE RESULTS OF ONE ANIMAL STUDY WHERE RATS INHALED TONER
THAT WAS TEN TIMES MORE RESPIRABLE THAN COMMERCIALLY AVAIL TONER
WERE OBSERVED TO HAVE NO LU NG CHANGES AT LOW EXPOS (THE MOST
RELEVANT LEVEL TO POTENTIAL HUMAN EXPOS). AT HIGHER LEVS A SLIGHT
DEGREE (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: WASH NOSTRILS, RINSE MOUTH. INGEST: DILUTE STOMACH
CONTENTS WITH SEVERAL GLASSES OF WATER. EYES: FLUSH WITH WATER FOR
AT LEAST 15 MINUTES. SKIN: WASH WITH SOAP AND WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. WHEN
DISPERSED IN AIR, IT FORMS EXPLOSIVE MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA
EQUIPMENT. IF NECESSARY, NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE
Supplemental Safety and Health
EFTS OF OVEREXP: OF LUNG FIBROSIS WAS OBSERVED DUE TO EXCESSIVE AMTS OF
DUST RETAINED IN THE LUNGS FOR A PROLONGED INTERVAL.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER, FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE. NO SPECIAL TECHNIQUES BEYOND
NORMAL PRACTICE. ENSURE CONFORMITY WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:104159 DNASE 1 DEOXYRIBONUCLEASE 1
CAGE:32239
CAGE:32239
============= Composition/Information on Ingredients =============
Ingred Name:DNASE 1 DEOXYRIBONUCLEASE I
CAS:9003-98-9
RTECS #:RF0750000
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:THE TOXICOLOGICAL PROPERTIES OF THIS
PRODUCT HAVE NOT BEEN DETERMINED.
Effects of Overexposure:THE TOXICOLOGICAL PROPERTIES OF THIS PRODUCT
HAVE NOT BEEN DETERMINED.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/LARGE VOLUMES OF WATER FOR 15 MINS.
INGESTION: KEEP WARM & CALM. INHALATION: REMOVE TO FRESH AIR. GIVE
OXYGEN IF BREATHING BECOMES DIFFICULT. SHOULD BREATHING STOP, GIVE
CPR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>200.C, 392.F
Extinguishing Media:USE MEDIA SPECIFIC FOR SITE CONDITIONS.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE GARMENTS. HAVE THIS PRODUCT REMOVED FROM THE FIRE SCENE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. IF PRODUCT IS DRY, MOP UP. IF
PRODUCT IS IN SOLUTION, USE AN ABSORBENT MATERIAL TO CLEAN UP THE
SPILLED SOLUTION. ONCE THE ABSORBENT IS SPENT, PLACE ALL
CONTAMINATED DISPOSABLES INTO A SUITABLE CONTAINER, SEAL, LABEL &
HOLD FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:SEE PACKAGE INSERT FOR STORAGE
INFORMATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF VENTILATION IS ADEQUATE.
Ventilation:ADEQUATE GENERAL EXHAUST
Other Protective Equipment:EYE WASH STATIONS, DELUGE SHOWERS, LAB COAT
Work Hygienic Practices:GOOD LABORATORY TECHNIQUE SHOULD BE USED WHEN
HANDLING THIS PRODUCT. REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. DON'T EAT, DRINK/SMOKE WHILE WORKING W/REAGENTS.
Supplemental Safety and Health
DON'T MOUTH PIPETTE. OBSERVE APPROPRIATE CHEMICAL HYGIENE & AVOID
CONTACT W/SKIN & EYES. UPON COMPLETION OF WORK ACTIVITIES INVOLVING
THIS PRODUCT, WASH ANY EXPOSED BODY AREAS THOROUGHLY W/SOAP & WATE
R.
================== Physical/Chemical Properties ==================
Solubility in Water:SLIGHTLY
Appearance and Odor:PRE-PACKED COLUMNS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXCESSIVE HEAT, FLAME, PRESSURE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2932 SPRED HOUSE DURA-SATIN FINISH
CAGE:01PD6
CAGE:72818
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:ACRYLIC COPOLYMER
Fraction by Wt: 20-30%
Ingred Name:ETHYLENE GLYCOL, GLYCOL
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 5-10%
Other REC Limits:10 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICA DIOXIDE, CRYSTALLINE QUARTZ, SAND (SUSPECTED HUMAN
CARCINOGEN BY IARC)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 10-20%
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:TITANIUM DIOXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1-5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:PROPANOIC ACID, 2-METHYL, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL, TEXANOL(ESTER ALCOHOL)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 1-5%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 50-60%
Ingred Name:FORMALDEHYDE, FORMALIN (2A CARCINOGEN BY NTP, IARC, OSHA)
INTENDED CHANGE
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: <0.1%
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM; A2; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:WEIGHT PER GALLON IN POUNDS: 9.5
RTECS #:9999999WG
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF RESPIRATORY
TRACT. SKIN: IRRITATION & ALLERGIC SENSITIZATION. EYES: IRRITATION.
INGESTION: SERIOUS INJURY.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:INHALATION: MUCOUS MEMBRANE IRRITATION,
DROWSINESS, DIZZINESS, LIGHTHEADEDNESS, HEADACHE, NAUSEA,
SILICOSIS. INGESTION: KIDNEY DAMAGE AND/OR FAILURE.
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY, LUNG, &
KIDNEY DISORDERS
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR OR OXYGEN IF
NEEDED. SKIN: WASH W/PLENTY OF WATER, THEN SOAP & WATER. EYES:
FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. INGESTION: OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>200F
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY W/ALL APPLICABLE HEALTH & ENVIRONMENTAL
REGULATIONS. VENTILATE AREA. COLLECT W/ABSORBENT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <100F. KEEP FROM FREEZING. USE
ONLY W/ADEQUATE VENTILATION. KEEP CONTAINERS TIGHTLY CLOSED &
UPRIGHT WHEN NOT IN USE. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT W/SKIN,
EYES, & BREATHING VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF SPRAYING OR ABRADING (SANDING) PAINTED
SURFACES, USE APPROPRIATE RESPIRATORY PROTECTION (NIOSH/MSHA).
CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW APPLICABLE STANDARDS.
Ventilation:DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT BUILD-UP
OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS THOROUGHLY AFTER HANDLING, BEFORE EATING, OR
SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text: 212F
Percent Volatiles by Volume:69.8%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, HYDROFLUORIC ACID
Stability Condition to Avoid:ELEVATED TEMPERATURES >100F, FREEZING,
FIRE
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GLAZING-WHITE
Preparer's Name:TIMOTHY J. COLLITON
CAGE:IO199
CAGE:PERME
CAGE:IO199
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM CARBONATE; (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 100%
OSHA PEL:15MG/M3 TDUST;5 RESP
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
CAS:14807-96-6
RTECS #:WW2710000
Other REC Limits:20 MPPCF (MFR)
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:NON HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION OF DUST GENERATED FROM
DRIED PRODUCT MAY CAUSE RESPIRATORY IRRITATION. PROLONGED CONTACT
MAY CAUSE MILD SKIN IRRITATION IN SENSITIVE INDIVIDUALS. EYE
CONTACT MAY CAUSE IRRITATION. CHRONIC O VEREXPOSURE TO TALC MAY
CAUSE PNEUMOCONIOSIS (LUNG DAMAGE).
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MIN.
GET MED ATTN IF IRRITATION PERSISTS. SKIN: WIPE MATERIAL FROM SKIN
WITH CLOTH OR PAPER TOWEL, THEN WASH EXPOSED AREA WITH SOAP AND
WATER. G ET MEDICAL HELP IF IRRITATION PERSISTS.INHAL: MOVE VICTIM
TO FRESH AIR. GET MEDICAL HELP IF IRRITATION PERSISTS. INGEST:
CONTACT LOCAL POISON CONTROL CENTER OR PHYSICIAN IMMEDIATELY!
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING MATERIALS.
Fire Fighting Procedures:NO SPECIAL PROCEDURES REQUIRED. WEAR
NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP WITH ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINER. THIS
PRODUCT DOES NOT CONTAIN ANY CARCINOGENS AS DEFINED BY IARC, NTP,
OR OSHA.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. IF AIRBORNE PARTICULATES
ARE GENERATED, USE A NIOSH/MSHA APPROVED DUST/MIST RESPIRATOR.
Ventilation:LOC EXHST MAY BE NEC UNDER SOME HNDLG/USE CNDTNS. SPEC
NEEDS SHOULD BE ADDRESSED BY SUPERVISORY/HLTH/SAFETY PERSONNEL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:> 1 (H*2O=1)
Solubility in Water:SLIGHT
Appearance and Odor:WHITE PASTE; SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:UNLEADED GASOLINE
CAGE:1JX71
CAGE:1JX71
============= Composition/Information on Ingredients =============
Ingred Name:GASOLINE (INCLUDING INGREDIENTS 2, 3, 4 AND 5)
CAS:8006-61-9
RTECS #:LX3300000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM/500 STEL
ACGIH TLV:300 PPM/500STEL;9293
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE-HIGH VAPOR CONCENTRATIONS MAY
CAUSE CNS
DEPRESSION;I.E.HEADACHE,NAUSEA,DROWSINESS,DIZZINESS.ACCIDENTAL
INGESTION MAY CAUSE SIMILAR SYMPTOMS.IT IS AN ASPIRATION HAZARD.MAY
CAUSE EYE IRRITATION,RE DNESS,TEARING & BURNING.PROLONGED/REPEATED
SKIN CONTACT CAN CAUSE IRRITATION,DEFATTING &
DERMATITIS.CHRONIC-DERMATITIS.
Explanation of Carcinogenicity:CONTAINS BENZENE.MAY CAUSE BLOOD
DISEASES INCLUDING LEUKEMIA.VAPORS MAY CAUSE KIDNEY CANCER IN MALE
RATS.
Effects of Overexposure:HIGH VAPOR CONCENTRATIONS MAY CAUSE CNS
DEPRESSION; I.E. HEADACHE, NAUSEA, DROWSINESS, DIZZINESS.
ACCIDENTAL INGESTION MAY CAUSE SIMILAR SYMPTOMS. IT IS AN
ASPIRATION HAZARD. MAY CAUSE EYE IRRITATION, REDNESS, TEARING &
BURNING. PROLONGED/REPEATED SKIN CONTACT CAN CAUSE IRRITATION,
DEFATTING & DERMATITIS.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE
TO THE EFFECTS OF THE SUBSTANCE.
======================= First Aid Measures =======================
First Aid:CALL A PHYSICIAN IN ALL CASES.EYES:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES,HOLDING EYELIDS OPEN.SKIN:WASH WITH SOAP &
WATER.INHALED:REMOVE TO FRESH AIR & PROVIDE CPR/OXYGEN IF
NECESSARY.ORAL:DO NO T INDUCE VOMITING.CALL A PHYSICIAN
IMMEDIATELY.IF CONSCIOUS,DRINK MILK OR WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:-45F,-43C
Autoignition Temp:Autoignition Temp Text:536F
Lower Limits:1.2%
Upper Limits:7.6%
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, DRY CHEMICAL
OR HALON. WATER MAY BE INEFFECTIVE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT & A
FULL FACED SELF CONTAINED BREATHING APPARATUS/SUPPLIED-AIR
RESPIRATOR.COOL FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:SEVERE FIRE & EXPLOSION HAZARD INDOORS,
OUTDOORS OR SEWERS. VAPORS MAY TRAVEL TO IGNITION SOURCE & FLASH
BACK. CONTAINERS MAY EXPLODE IN FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENTS.ELIMINATE ALL
SOURCES OF IGNITION.USE EXPLOSION-PROOF TOOLS.SHUT OFF FUEL
SOURCE.DIKE SPILL.PREVENT LIQUID FROM ENTERING
SEWERS/WATERWAYS.RECOVER FREE LIQUID.ADD SAND,EARTH OR OTHER
ABSORBENT MATERIAL.TRANSFER TOCONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-STORE IN ACCORDANCE WITH
NATIONAL FIRE PROTECTION ASSOCIATION REGULATIONS.KEEP CONTAINERS
CLOSED.HANDLE IN WELL-VENTILATED AREA.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE AND CAN BE
DANGEROUS.DO NOT PRESSURIZE,CUT,WELD,BRAZE,SOLDER,DRILL,GRIND OR
EXPOSE SUCH CONTAINERS TO HEAT,FLAME,SPARKS.THEY MAY EXPLODE AND
CAUSE INJURY/DEATH.AVOID REPEATED OR PROLONGED CONTACT WITH SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS OR ORGANIC VAPOR RESPIRATOR OR SUPPLIED-AIR RESPIRATOR,
IF NEEDED.
Ventilation:LOCAL/MECHANICAL (GENERAL) VENTILATION - EXPLOSION PROOF,
WELL GROUNDED EQUIPMENTS
Other Protective Equipment:IMPERVIOUS CLOTHING TO AVOID SKIN AND EYE
CONTACT. EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH EYES, SKIN OR CLOTHING. WASH
HANDS AFTER USING PRODUCT. AVOID BREATHING VAPORS OR MISTS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F1
Boiling Pt:B.P. Text:75.0F,23.9C
Vapor Pres:414 - 724
Vapor Density:>1
Spec Gravity:0.74 - 0.79
Viscosity:<30 SSU @100F
Evaporation Rate & Reference:<1 (ETHER = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, RED LIQUID - CHARACTERISTIC GASOLINE ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES, STATIC
ELECTRICITY AND OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE. MAY
FORM ACRID SMOKE AND IRRITATING FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:TREATMENT, STORAGE, TRANSPORTATION AND DISPOSAL
MUST BE IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE AND FEDERAL
LAWS AND REGULATIONS. THIS MATERIAL IS CLASSIFIED BY THE EPA AS A
HAZARDOUS WASTE UND ER RCRA. NO. D001 IGNITABLE WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AMPEX HEAD CLEANER PART NO 050-104 FREON TF
CAGE:4A424
CAGE:4A424
============= Composition/Information on Ingredients =============
Ingred Name:1,1,2-TRICHLORO-1,2,2-TRIFLUOROETHANE (FREON 113) (SARA
III)
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: 99.76%
Other REC Limits:1000 PPM
OSHA PEL:1000PPM/1250STEL
ACGIH TLV:1000PPM/1250STEL9192
Ozone Depleting Chemical:1
Ingred Name:NITROMETHANE
CAS:75-52-5
RTECS #:PA9800000
Fraction by Wt: 0.24%
Other REC Limits:N/K
OSHA PEL:100 PPM
ACGIH TLV:100 PPM; 9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:500 MG OPEN SKIN RABBIT MLD IRRT SUP DAT
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:FREON TF.IRRITANT/NARCOTIC.4500 PPM
IMMEDIATELY DANGEROUS TO LIFE OR HEALTH.ACUTE:MAY CAUSE MILD THROAT
IRRIT,DROWSINESS,HDACHE,UNCONSCIOUSNESS,CARDIAC ARRHYTMIAS &
ASPHYXIA.CHRONIC:ANIMAL STUDIES IND ICATE THAT SOME FLUORCARBONS
CAUSE SENSITIZATION TO CARDIAC ARRYTHMIAS.
Explanation of Carcinogenicity:N/A FPN
Effects of Overexposure:SKIN:ACUTE EXPOS MAY CAUSE RED & IRRIT
CHRONIC;MAY CAUSE DERMATITIS.EYE,ACUTE,EXPOS,POS IRRIT,W/ RED
EDEMA.CHRONIC CONJUNCTIVITIS.INGEST:ACUTE MILD THROAT IRRIT
DROWSEY,HDACHE.LOSS CONCENTRATION,NAUSE A INCOORDINATION.NARCOSIS
UNCONSCIOUS CARDIAC ARRYTHMIAS CONVULSION & ASPHYXIA.
Medical Cond Aggravated by Exposure:ADVISE AGAINST USE OF EPINEPHRINE
TYPE DRUGS (GE MSDS)
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOS TO FRESH AIR,BREATH STOPPED-PERFORM
ARTIFICIAL RESP,GET MED ATTN.SKIN:REMOVE CONTAM CLOTHES,IMMED WASH
W/SOAP & H*2O(LG AMTS) APPROX 15-20 MIN.GET MED ATTN.EYE:WASH IMMED
W/LG AMTS OF H*2O OCC LIFT UPPER & LOWER LIDS FOR 15-20 MIN.GET
MED ATT.INGEST:INDUCE VOMITING.GET MED ATTENTION.ADVISE AGAINST USE
OF EPINEPHRINE TYPE DRUGS (GE MSDS).
===================== Fire Fighting Measures =====================
Flash Point:NEGLI SUP DATA
Lower Limits:
Upper Limits:
Extinguishing Media:DRY CHEMICAL,CARBON DIOXIDE,WATER SPRAY OR FOAM,FOR
LG FIRES USE H*2O SPRAY OR FOAM,FOG.
Fire Fighting Procedures:MOVE CONTR FROM FIRE DON'T SCATTER SPILLED MAT
W/MORE H*2O THAN NEEDED FOR CONTRL,DIKE H*2O FOR LATER
DISPOSAL.WEAR PRESS DEMAND SCBA & FULL PROT EQUIP .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE FLUORIDES,CHLORIDES & PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK IF YOU CAN DO IT W/OUT RISK.SM
SPILLS TAKE UP W/ SAND OR OTHER ABSORBENT MAT & PLACE INTO
CLEAN,DRY CONTR FOR LATER DISPOSAL.KEEP UNNECESSARY PEOPLE AWAY.
ISOLATE HAZ AREA & DENY ENTRY.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINERS IN CLEAN DRY AREA.
Other Precautions:NO SMOKING IN AREA OF USE.DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING,OPEN FLAMES OR HOT SURFACES,HEAT &/OR UV
RADIATION MAY CAUSE THE FORMATION OF CHLORIDES,FLUORIDES OR
PHOSGENE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THE SPECIFIC RESP SELECTED MUST BE BASED ON
CONTAM LEVELS FOUND IN THE WORK PLACE & BE JOINTLY APPROVED BY
NIOSH/MSHA.
Ventilation:PROVIDE GENERAL DILUTION VENT TO MEET PUBLISHED EXPOSURE
LIMITS.
Other Protective Equipment:WEAR APPROPRIATE PROTECTIVE(IMPERVIOUS)
CLOTHING & EQUIP TO PREVENT RPT/PROLONGED SKIN CONTACT W/ THIS
SUBSTANCE.
Work Hygienic Practices:OBSERVE GOOD WORK HYGIENIC PRACTICES.
Supplemental Safety and Health
FL PT:FIRE HAZARD WHEN EXPOSED TO HEAT OR FLAME.AUTOIGNITION
TEMP.1256F(680C).LD50-LC50 MIX125PPH/90 SECOND INHAL MOUSE
LCLO;43GM/KG ORAL(RAT) LD50:87;000PPM/6 HR.INHAL RAT LCLO.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:114.4F,45 C
Melt/Freeze Pt:M.P/F.P Text:55.8F,13.2C
Decomp Temp:Decomp Text:
Vapor Pres:284 MM HG
Vapor Density:ABOUT 6
Spec Gravity:1.6
pH:
Evaporation Rate & Reference:0.45 ACETONE=1
Solubility in Water:0.028%
Appearance and Odor:CLEAR,COLORLESS LIQUID WITH A CHLOROFORM-LIKE ODOR.
Percent Volatiles by Volume:
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
POTASSIUM ALLOY;SODIUM,BARIUM,LITHIUM,FRESH SAMARIUM
SURFACE;TITANIUM,AL,FRESH AL SURFACE,CALCIUM MAGNESIUM BERYLLIUM.
Stability Condition to Avoid:
Hazardous Decomposition Products:WHEN HEATED TO DECOMP MAY EMIT HIGHLY
TOXIC VAPOR OF CHLORINE,FLUORINE,HYDORGEN FLUORIDE,HYDROGEN
CHLORIDE,CARBONYL,NALI
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE & LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TT-E-487E & AMD, 1 CLR NO 16251, B48716251
Preparer's Name:PATRICIA SHAW
CAGE:HO931
CAGE:3Z268
CAGE:HO931
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCARBON MIXTURE (VAPOR PRESSURE 2.0 MM HG @ 68 F)
CAS:64741-41-9
Fraction by Wt: 30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: NASAL, RESP IRRIT, NARCOSIS
(CNTRL NERV SYS DEPRESS). EYE: SEVERE IRRIT. SKIN: MOD IRRIT,
DEFAT, DERMATITIS. INGEST: DIGEST TRACT IRRIT, CNTRL NERV SYS
DEPRESS. ASPIRATION HZD-MAT'L ENTERS LUNG DURING
SWALLOW/VOMIT-CAUSE LUNG INFLAMM. CHRONIC: CNTRL NERV
SYS/RESP/LUNG/EYE/SKIN/GI TRACT/LIVER/SPLEEN/KIDNEY DAMAGE
Effects of Overexposure:INHAL: DIZZINESS, WEAKNESS, FATIGUE, NAUSEA,
HEADACHE. EYE: TEARING, REDNESS, BLURRED VISION.
Medical Cond Aggravated by Exposure:RESPIRATORY TRACT IRRITATION,
DERMATITIS, NAUSEA.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER 15 MIN, LIFTING EYELIDS. GET MED AID.
SKIN: REMOVE CONTAMINATED CLOTHES, WASH W/SOAP & WATER. IF IRRIT
PERSISTS, SEE DR. INHAL: REMOVE TO FRESH AIR. APPLY ARTIF RESP OR
ADMINISTED O XYGEN IF NEEDED. CONSULT DR. INGEST: GIVE WATER/MILK
DIRECTED TO DO SO BY MED PERSONNEL. IF MED ADVICE UNAVAIL, TAKE TO
NEAREST EMERG HOSP.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:104F,40C
Lower Limits:1.0
Upper Limits:6.1
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:EXTINGUISHERS FOR NFPA FLAMMABLE LIQUID FIRES.
WATER MAY BE INEFFECTIVE, USE AS FOG TO COOL EXPOSED CNTNRS. WEAR
FULL PROTECTIVE CLOTHING & BREATHING APP.
Unusual Fire/Explosion Hazard:VAPOR FORM EXPLOSIVE MIXTURE WITH AIR
(LEL TO UEL), CAN BE IGNITED BY MANY SOURCES. CLOSED CNTNRS MAY
EXPLODE W/HEAT. ISOLATE FROM ELECTRIC EQUIP, SPARK, FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL IGNITION SOURCES. VENTILATE THE AREA. PROVIDE APPROPRIATE
PROTECTIVE EQUIPMENT. DIKE AROUND THE SPILL AREA. COVER SPILL WITH
INERT ABSORBENT AND TRANSF ER USING NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 80 F IN (ORIGINAL) CLOSED
CNTNR. AVOID FLAME & HIGH TEMPERATURES. DO NOT STORE NEAR OXIDIZING
AGENTS OR ACIDS.
Other Precautions:VAPOR IS HEAVIER THAN AIR & MAY TRAVEL DISTANCE TO
SOURCE OF IGNITION & FLASHBACK. DON'T INGEST, AVOID BREATHING
HEATED VAPOR/ MIST. KEEP AWAY FROM HEAT. GROUND ALL CONNECTIONS,
CONTAINERS, ETC WHEN P OURING/TRANSFERING. USE NON-SPARK TOOLS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA EQUIP WHEN AIRBORN EXPOSURE
LIMITS EXCEEDED. CONSULT RESPIRATOR MFR TO DETERMINE EQUIP FOR
GIVEN APPLICATION. HIGH AIRBORN CONCENTRATIONS MAY REQUIRE USE OF A
SUPPLIED-AIR RESPIRATOR ORSELF-CONTAINED BREATHING APPARATUS.
Ventilation:PROVIDE SUFFICIENT VENT TO CONTROL EXPOSURE LEVELS BELOW
TLV/ PEL. VENTILATION MUST BE EXPLOSION PROOF.
Other Protective Equipment:WEAR IMPERMEABLE APRONS & PROTECT CLOTHING
WHEN POSSIBLE TO PREVENT SKIN EXPOSURE. USE HEAD CAPS WHEN
POSSIBLE.
Work Hygienic Practices:AFTER USING, WASH BEFORE EATING, TOILETING OR
SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:315F,157C
Vapor Density:> AIR.
Spec Gravity:1.2 (WATER=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT WATER SOLUBLE
Appearance and Odor:PIGMENTED LIQUID. SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT EXPOSE TO HEAT OR IGNITION SOURCES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE AND/OR MONOXIDE, LOW MOLECULAR WEIGHT HYDROCARBONS AND
ORGANIC ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP OUT OF DRAINS, SEWERS AND WATERWAYS.
DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:02317 MULTIGEAR LUBT EP SAE 85-140
Preparer's Name:M. J. VON ALLMEN
CAGE:7B131
CAGE:7B131
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED C25 BRIGHT STOCK BASED LUBRICATING OIL
CAS:72623-83-7
Fraction by Wt: 80-95%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY
PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: 1-4%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:SULFUR-CONTAINING C4-C8 OLEFIN
Fraction by Wt: 1-4%
Other REC Limits:NONE SPECIFIED
Ingred Name:DEFOAMANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL RAT > 20 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE EFFECTS-EYE CONTACT:SLIGHT TO
MODERATE IRRITATION. SKIN CONTACT:SLIGHTLY IRRITATING.
INHALATION:MINIMALLY IRRITATING. CHRONIC EFFECTS:NONE SPECIFIED BY
MANUFACTURER.
Effects of Overexposure:EYE CONTACT:SLIGHT TO MODERATE IRRITATION.
SKIN:REDNESS,EDEMA,DRYING OF SKIN. INHALATION:MINIMALLY IRRITATING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR 15 MINUTES.SEE DOCTOR.
SKIN:REMOVE CONTAMINATED CLOTHING AND SHOES. WASH WITH SOAP AND
WATER. INHALATION: REMOVE VICTIM TO FRESH AIR. INGESTION: SEE
DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:385F,196C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS LIKE CARBON
MONOXIDE, CARBON DIOXIDE, ALDEHYDES, KETONES, NITROGEN & SULFUR
OXID
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE AREA.
WEAR PROPER PROTECTIVE EQUIPMENT. STOP LEAK. ABSORB IN INERT
ABSORBENT AND PLACE INTO APPROPIATE DISPOSAL CONTAINER AND COVER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
PLACE,AWAY FROM HEAT,IGNITION SOURCES AND INCOMPATIBLE
MATERIALS.KEEP CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:MINIMUM FEASIBLE HANLDING TEMPERATURES SHOULD BE
MAINTAINED. PERIODS OF EXPOSURE TO HIGH TEMPERATURES SHOULD BE
MINIMIZED. WATER CONTAMINATION SHOULD BE AVOIDED. AVOID BREATHING
VAPORS, AND EYE AND SK IN CONTACT. USE WITH ADEQUATE VENTILATN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. NIOSH/MSHA RESPIRATOR
WITH ORGANIC VAPOR CARTRIDGE APPROPIATE FOR EXPOSURE OF CONCERN OR
SCBA IF TLV IS EXCEEDED.
Ventilation:SUFFICIENT MECHANICAL (GENERAL) AND/OR LOCAL EXHAUST
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED SKIN CONTACT. EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH EYES & SKIN.DO NOT BREATHE
VAPORS.WASH THOROUGHLY AFTER HANDLING.LAUNDER CONTAMINATED
CLOTHING.
Supplemental Safety and Health
THESE PRECAUTIONS ARE FOR ROOM TEMPERATURE HANDLING. USE AT ELEVATED
TEMPERATURES MAY REQUIRE ADDED PRECAUTIONS.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:615F,324C
Spec Gravity:0.9117
Viscosity:25 CST @ 212F
Appearance and Odor:RED, GREEN BLOOM OIL.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
ALDEHYDES, KETONES, COMBUSTION PRODUCTS OF NITROGEN AND SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AROCLOR 1260 MIX, 32112
CAGE:IO729
CAGE:0JL17
CAGE:IO729
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE; (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 99.9%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POLYCHLORINATED BIPHENYL (AROCLOR 1260); (AROCLOR 1260)
(SARA III)
CAS:11096-82-5
RTECS #:TQ1362000
Fraction by Wt: 0.1%
OSHA PEL:1 MG/M3 (MFR)
ACGIH TLV:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITANT, CONVULSIONS,
UNCONSCIOUSNESS. CHRONIC:DERMATITIS. CANCER HAZARD.
Explanation of Carcinogenicity:AROCLOR 1260:NTP 6TH ANNUAL REPORT ON
CARCINOGENS, 1991:ANTICIPATED TO BE CARCINOGEN. ANIMAL:LIVER.
Effects of Overexposure:DRYNESS & ITCHING; MILD DEPRESSION,
CONVULSIONS, UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES:REMOVE CONT LENSES IF PRESENT. HOLD EYELIDS OPEN &
IRRIGATE W/LG VOL OF WATER FOR AT LST 15 MINS. SEEK MED TREATMENT.
SKIN:IMMED WASH W/SOAP & WATER. CONTINUE RINSING W/LG VOL OF WATER
FOR 15 MIN S. INHAL:REMOVE TO FRESH AIR. RESTORE &/OR SUPPORT
BRTHG. HAVE TRAINED PERS ADMIN OXYGEN IF NEEDED. SEEK MED
TREATMENT. INGEST:DRINK LG QTYS OF WATER. DO NOT INDUCE VOMIT. CONT
POIS CTL CTR.
===================== Fire Fighting Measures =====================
Flash Point:-9F,-23C
Lower Limits:1.2%
Upper Limits:7.7%
Extinguishing Media:DRY CHEMICAL, CO*2, HALON, ALCOHOLS, FOAM, WATER
SPRAY AS APPROPRIATE FOR SURROUNDING FIRE & MATERIALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . KEEP FIRE-EXPOSED CONTAINERS COOL W/WATER SPRAY.
Unusual Fire/Explosion Hazard:MAY FORM EXPLOSIVE VAPOR/AIR MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PERSONAL PROTECTIVE EQUIPMENT. ABSORB
SMALL SPILLS ON PAPER, VERMICULITE OR OTHER ABSORBENT. COLLECT &
STORE IN CLOSED CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINS CARCIN/SUSPECTED CARCIN.
HANDLE W/UTMOST CARE. AVOID ALL CONT & INHAL. STORE IN EXPLO PROOF
REFRIGERATOR AT 4C.
Other Precautions:KEEP IN TIGHTLY CLSD CNTNR AT ALL TIMES. PERS NOT
SPECIFICALLY TRAINED SHOULD NOT HANDLE THIS CHEM/ITS CNTNR. THIS
PROD IS FURNISHED FOR LAB USE ONLY! MFR'S PRODS MAY NOT BE USED AS
DRUGS, COSMETICS, AGRICULTURAL/PESTICIDAL PRODS, (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR W/ORGANIC VAPOR
CARTRIDGE.
Ventilation:USE IN AN AREA PROVIDED W/GENERAL & LOCAL EXHAUST
VENTILATION MEETING OSHA REQUIREMENTS.
Other Protective Equipment:PROTECTIVE CLOTHING MEETING LABORATORY
SAFETY REQUIREMENTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PREC:OR AS HOUSEHOLD CHEMICALS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>151F,>66C
Vapor Pres:124 @ 20C
Spec Gravity:0.66
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS; HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS LIKE LIQUID CHLORINE & CONCENTRATED OXYGEN.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE AT AN APPROVED FACILITY I/A/W
FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SODIUM THIOSULFATE PENTAHYDRATE PURE, S445 50
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM THIOSULFATE, PENTAHYDRATE
CAS:10102-17-7
RTECS #:WE6660000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT): 2700 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MAY CAUSE MILD
IRRITATION. SKIN: PROLONGED AND/OR REPEATED CONTACT MAY CAUSE
IRRITATION AND/OR DERMATITIS. INGESTION: LARGE AMOUNTS MAY CAUSE
GASTROINTESTINAL IRRITATION. INHALATION: LOW HAZARD FOR USUAL
INDUSTRIAL HANDLING. MAY CAUSE RESPIRATORY TRACT IRRITATION.
CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN, OCCAS
LIFTING UPPER & LOWER LIDS. GET MED AID. SKIN: FLUSH W/PLENTY OF
SOAP & WATER FOR AT LEAST 15 MIN WHILE REMOVING CONTAM CLTHG &
SHOES. GET MED AID IF IRRIT DEVELOPS/PERSISTS. INGEST:IF CONSCIOUS
& ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. GET MED AID. INHAL: REMOVE
TO FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS
DFCLT, (SUP DAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:FOR SMALL FIRES, USE WATER SPRAY, DRY CHEMICAL,
CARBON DIOXIDE OR CHEMICAL FOAMS.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM OR SWEEP UP MATERIAL AND PLACE INTO A
SUITABLE DISPOSAL CONTAINER. AVOID GENERATING DUSTY CONDITIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED OR REPEATED CONTACT
WITH SKIN. AVOID INGESTION AND INHALATION. USE WITH ADEQUATE
VENTILATION.
Other Precautions:STORE IN A TIGHTLY CLOSED CONTAINER. KEEP FROM
CONTACT WITH OXIDIZING MATERIALS. KEEP AWAY FROM STRONG ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29CFR 1910.134. ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE VENTILATION TO KEEP AIRBORNE CONCENTRATIONS
LOW.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . WEAR APPROPRIATE CLOTHING TO PREVENT SKIN CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: GIVE OXYGEN. GET MED AID. NOTES TO MD: TREAT
SYMPTOMATICALLY & SUPPORTIVELY. ANTIDOTE: NONE REPORTED.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:119F,49C
Spec Gravity:1.7290
Solubility in Water:680 G/L @ 20C
Appearance and Odor:COLORLESS TO WHITE CRYSTALS, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
VIOLENTLY REACTS WITH SODIUM NITRATE. IMCOMPATIBLE WITH STRONG
OXIDIZERS, ACIDS.
Stability Condition to Avoid:ACIDS, STRONG OXIDANTS.
Hazardous Decomposition Products:HYDROGEN SULFIDE, SODIUM OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SPIRITS OF TURPENTINE
Preparer's Name:ROBERT G. SCHORY
CAGE:KO005
CAGE:5W216
CAGE:KO005
============= Composition/Information on Ingredients =============
Ingred Name:TERPENE HYDROCARBONS
Fraction by Wt: 100%
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE IRRITATION, DERMATITAS
OF SKIN, MAY CAUSE KIDNEY INFECTIONS
Effects of Overexposure:MAY CAUSE EYE IRRITATION, DERMATITAS OF SKIN,
MAY CAUSE KIDNEY INFECTIONS
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER, CALL A PHYSICIAN. SKIN: WASH WITH SOAP
AND WATER. INHALATION: REMOVE TO FRESH AIR. IF SWALLOWED: DO NOT
INDUCE VOMITING, CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:105 F/40.56 C
Extinguishing Media:FOAM, DRY CHEMICAL, CO2
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCE, STOP SPILL AT ONCE,
CONTAIN SPILL BY DIKE, ETC. PUMP INTO SALVAGE TANK. AVOID CONTACT
WITH VAPOR OR SPRAY MIST
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL, KEEP AWAY FROM FLAMES OR HIGH
HEAT. USE ONLY WITH ADEQUATE VENTILATION. AVOID PROLONGED CONTATC
WITH SKIN
Other Precautions:AVOID CONTACT WITH OXIDIZING MATERIALS
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS NEEDED TO MAINTAIN CONCENTRATIONS BELOW TLV
LEVEL
Ventilation:LOCAL EXHAUST
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:307 F
Vapor Pres:760
Spec Gravity:.864
Evaporation Rate & Reference:1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR AND FREE OF SUSPENDED MATTER
Percent Volatiles by Volume:99.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NK
Stability Condition to Avoid:STRONG OXIDIZING MATERIALS
Conditions to Avoid Polymerization:CONTACT WITH STRONG ACIDS OR LEWIS
ACIDS
==================== Disposal Considerations ====================
Waste Disposal Methods:LIQUID INCINERATION
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BL862
CAGE:50450
CAGE:50450
============= Composition/Information on Ingredients =============
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
================== Accidental Release Measures ==================
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:A2
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED
| 1 | gloves_mandatory |
=======================================================
Product ID: BROMA 10 MINUTE DRY DECORATIVE ENAMEL, 107 GLOSS DOVE GRAY
Cage: 90300
Box: 277
Resp. Party Other MSDS No.: 21006 REV. 3
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 90300
Box: 277
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: OVEREXPOSURE OR MISUSE OF TOLUENE CAN CAUSE LIVER,
KIDNEY AND BRAIN DAMAGE. MAY IRRITATE EYES, SKIN, NOSE AND RESPIRATORY TRACT.
HARMFUL IF INHALED. HARMFUL OR FATAL IF SWALLOWED. IF INGESTED C AUSES
VOMITING, DIARRHEA AND DEPRESSED RESPIRATION. INHALATION MAY AFFECT THE BRAIN
OR NERVOUS SYSTEM CAUSING DIZZINESS, HEADACHE OR NAUSEA. CHRONIC: REPORTS
HAVE ASSOCIATED PROLONGED AND REPEATED OCC UPATIONAL OVEREXPOSURE TO SOLVENTS
WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. PROLONGED OR REPEATED CONTACT
CAN CAUSE DEFATTING OF THE SKIN LEADING TO DERMATITIS. INTENTIONAL MISUSE BY
DELIBERATE LY CONCENTRATING AND (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: THIS PRODUCT IS NOT CONSIDERED A CARCINOGEN BY
NTP, OSHA AND IARC.
Signs And Symptions Of Overexposure: HLTH HAZ: INHALING VAPORS MAY BE HARMFUL
OR FATAL. NOTE:TOLUENE APPEARS ON THE NAVY LIST OF OCCUPATIONAL CHEMICAL
REPRODUCTIVE HAZARDS. SEEK CONSULTATION FROM APPROPRIATE HEALTH PROFESSIONALS
CONCERNI NG LATEST HAZARD LIST INFORMATION & SAFE HANDLING & EXPOSURE
INFORMATION (FP N).
Medical Cond Aggravated By Exposure: NONE KNOWN.
First Aid: EYE: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. CALL
MD IMMEDIATELY. SKIN: WASH IMMEDIATELY WITH SOAP AND WATER. INHALATION:
REMOVE TO FRESH AIR. CONTACT MD IMMEDIATELY. INGESTION: DO NOT INDUCE
VOMITING. CONTACT MD OR REGIONAL POISON CONTROL CENTER IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: USE ABSORBENT MATERIAL OR SCRAPE UP DRIED MATERIAL
AND PLACE INTO CONTAINERS.
Waste Disposal Methods: USE ALL MATERIAL BEFORE DISPOSAL. IF UNABLE, RELIEVE
PRESSURE IN CONTAINER UNTIL IT EQUALS EXTERNAL PRESSURE. DISPOSE OF ACCORDING
TO FEDERAL, STATE AND LOCAL REGULATIONS. EPA WASTE CODE - IF DISCARDE D (40
CFR 261): D001 - IGNITABLE.
Handling And Storage Precautions: STORE AWAY FROM CAUSTICS AND OXIDIZERS. KEEP
CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. KEEP OUT OF REACH OF CHILDREN.
KEEP CONTAINERS FROM EXCESSIVE HEAT AND FREEZING. DO NOT STORE AT
TEMPERATURES AB OVE 120F.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: AEROSOL
Lower Limits: NE
Upper Limits: NE
Extinguishing Media: FOAM, CARBON DIOXIDE, DRY CHEMICALS
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N). COOL EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard: CONTAINERS MAY EXPLODE IF EXPOSED TO EXTREME
HEAT. ELIMINATE SOURCE OF IGNITION: HEAT, ELECTRICAL EQUIPMENT, SPARKS AND
OPEN FLAMES. DO NOT PUT IN CONTACT WITH OXIDIZING OR CAUSTIC MATERIALS. NPCA
& H MIS RATINGS: HEALTH - 2; FLAMMABILITY - 4; REACTIVITY - 0. PERSONAL
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF 8-HOUR EXPOSURE LIMIT OR VALUE IS EXCEEDED FOR ANY
COMPONENT, USE A NIOSH APPROVED RESPIRATOR. CONSULT YOUR SAFETY EQUIPMENT
SUPPLIER AND OSHA REGULATION, 29 CFR 1910.134 FOR RESPIRATOR REQUIREMENT S.
Ventilation: PROVIDE SUFFICIENT MECH VENT (LOC/GEN EXHST) TO MAINTAIN EXPOS
BELOW PEL & TLV. VAPS ARE HVR/AIR & WILL COLLECT IN LOW AREAS. CHECK
ALL LOW AREAS (SUPP DATA)
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
SOLVENT IMPERVIOUS APRON IF BODY CONTACT WITH PRODUCT OCCURS. BARRIER CREAMS
MAY BE USED.
Work Hygienic Practices: WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health: VENT: (BASEMENTS, SUMPS, ETC) FOR VAPOR BEFORE
ENTERING. -- PHYSICAL DATA: VOC - MATERIAL & LESS WATER LESS EXEMPT
SOLVENT: 610 G/L.
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Pres: SEE INGREDIENTS
Vapor Density: >1 (AIR=1)
Spec Gravity: 0.88 - 0.98 (H*2O=1)
VOC Grams/Liter: 610
Evaporation Rate & Reference: >1 (N-BUTYL ACETATE=1)
Solubility in Water: NEGLIGIBLE
Appearance and Odor: OPAQUE LIQUID, VARIOUS COLORS; GASOLINE-LIKE ODOR.
Percent Volatiles by Volume: 80-90
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: MATERIAL IS STABLE AT ROOM TEMPERATURE. AVOID
EXCESSIVE HEAT AND FREEZING.
Materials To Avoid: STRONG OXIDIZERS AND CAUSTICS.
Hazardous Decomposition Products: NORMAL COMBUSTION PRODUCTS, I.E. CO*X, NO*X.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: HAZARDOUS POLYMERIZATION WILL NOT OCCUR.
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
Transport Information: DOT INFORMATION FOR DOMESTIC GROUND TRANSPORT: SHIPPING
NAME (40 CFR 172.101): CONSUMER COMMODITY (FOR 13 OZ AEROSOL). DOT HAZARD
CLASS (49 CFR 172.101): ORM-D (FOR 13 OZ AEROSOL). DOT ID NO (49 CFR 1
72.101: NONE (FOR 13 OZ AEROSOL). DOT LABEL REQUIRED (49 CFR 172.101): NONE
(FOR 13 OZ AEROSOL). DOT PACKAGING GROUP (49 CFR 172.101): NONE (FOR 13 OZ
AEROSOL).
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: ACETONE, TOLUENE, XYLENE, METHYL ETHYL KETONE AND
TRIMETHYLBENZENE ARE SUBJECT TO THE REPORTING REQUIREMENTS OF SARA TITLE III
SECTION 313.
Federal Regulatory Information: TRADE SECRET INGREDIENTS ARE NOT REGULATED BY
OSHA.
State Regulatory Information: WARNING! THIS PRODUCT CONTAINS A CHEMICAL KNOWN
TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS AND OTHER REPRODUCTIVE
HARM.
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: BROMA 10 MINUTE DRY DECORATIVE ENAMEL, 107 GLOSS DOVE GRAY
Cage: 90300
Company Name: DAP INC.
PO Box: 277
Zipcode: 45401-0277
Label Required IND: Y
Date Of Label Review: 05/22/2000
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: MAY CAUSE LIVER, KIDNEY & BRAIN DAMAGE. MAY
IRRITATE EYES, SKIN, NOSE & RESPIRATORY TRACT. HARMFUL IF INHALED OR
SWALLOWED. INGESTION: VOMIT, DIARRHEA & DEPRESSED RESPIRATION.
INHALATION: BRAIN /NERVOUS SYSTEM EFFECTS; CAUSING DIZZINESS,
HEADACHE/NAUSEA. CHRONIC: CONTAINS MATERIAL WHICH APPEARS ON NAVY SYSTEM
DAMAGE. CAN CAUSE DEFATTING OF SKIN LEADING TO DERMATITIS. MISUSE MAY BE
HARMFUL OR FATAL.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FA1814D
CAGE:JO867
CAGE:81831
CAGE:JO867
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR. AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UN CONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:031/601
CAGE:JO835
CAGE:40608
CAGE:JO835
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:T6
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2131 & 2341,I.M. SEMI-GLOSS ENAMEL
CAGE:OO128
CAGE:85260
CAGE:OO128
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 28%
OSHA PEL:100 PPM
Ingred Name:ALKYD RESIN
===================== Hazards Identification =====================
Effects of Overexposure:EYE/SKIN: IRRITATION. VAPORS:
HEADACHE,NAUSEA,EYE & LUNG IRRITATION.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER 15 MIN,GET MEDICAL ATTN. SKIN: WASH
WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR,GIVE ARTIF
RESP IF NEEDED,CONSULT PHYSICIAN. INGESTION: DO NOT INDUCE
VOMITING,CONSULT APHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:102F/38C (TCC)
Lower Limits:1.0
Extinguishing Media:FOAM,CO*2,DRY CHEMICAL,SAND,NFPA CLASS "B"
EXTINGUISHER
Fire Fighting Procedures:GENERAL PROCEDURES RECOMMENDED,AVOID USE OF
WATER
Unusual Fire/Explosion Hazard:CONTAINERS MAY RUPTURE DUE TO VERY HIGH
TEMPERATURE INDUCED PRESSURE
================== Accidental Release Measures ==================
Spill Release Procedures:ADD SOLID ABSORBANT,SHOVEL OR SCOOP INTO
DISPOSABLE CLOSED CONTAINERS. WASH AND HOSE DOWN AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID FLAME & HIGH TEMPERATURE STORAGE
& LOCALIZED SOLVENT VAPOR BUILD-UP. GROUND CONTAINERS WHEN
POURING,AVOID FREE FALL IN EXCESS OF FEW INCHES
Other Precautions:DO NOT TAKE INTERNALLY,AVOID PROLONG CONTACT OR
INHALATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN
Ventilation:LOCAL/MECHANICAL WITH EXPLOSION PROOF MOTORS
Supplemental Safety and Health
WEIGHT PER GAL: 11.30 LB
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:314F/156C
Vapor Density:>1
Evaporation Rate & Reference:<1 (ETHER)
Percent Volatiles by Volume:47
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO,CO*2,LOW MOLECULAR WEIGHT
HYDROCARBONS & ORGANIC ACIDS
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EPOXYLITE 293,PART B
Kit Part:Y
Preparer's Name:REBECCA A. TIMMINS
CAGE:11147
CAGE:11147
============= Composition/Information on Ingredients =============
Ingred Name:"NOT HAZARDOUS"
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYES:MAY CAUSE IRRITATION WITH
TEARING.SKIN:MAY CAUSE IRRITATION.MAY CAUSE ALLERGIC SENSITIVITY IN
SOME INDIVIDUALS.INHALE:MAY CAUSE BREATHLESSNESS,SEVERE
COUGHING,CHEST DISCOMFORT,IRRITATION OF MUCOUS MEMBRANE & REDUCED
PULMONARY FUNCTION.ORAL:VOMITING,IRRITATION & POSSIBLE CORROSIVE
ACTION.CHRONIC-NONE KNOWN.
Effects of Overexposure:MAY CAUSE EYE IRRITATION WITH TEARING. MAY
CAUSE SKIN IRRITATION. MAY CAUSE ALLERGIC SENSITIVITY IN SOME
INDIVIDUALS. INHALATION MAY LEAD TO BREATHLESSNESS, SEVERE
COUGHING, CHEST DISCOMFORT, IRRITATI ON OF MUCOUS MEMBRANE &
REDUCED PULMONARY FUNCTION. ORAL: VOMITING, IRRITATION & POSSIBLE
CORROSIVE ACTION ON MOUTH ETC.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE
TO THE EFFECTS OF THE SUBSTANCE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF NECESSARY.EYE:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES,HOLDING EYELIDS OPEN.SKIN:WASH WITH SOAP &
WATER.INHALED:REMOVE TO FRESH AIR.PROVIDE CPR/OXYGEN IF
NEEDED.ORAL:IF CON SCIOUS,DRINK WARM WATER & INDUCE
VOMITING.THEN,DRINK MILK WITH MILK OF MAGNESIA.GET MEDICAL
ASSISTANCE OR CALL POISON CONTROL CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:275F,135C
Extinguishing Media:WATER FOG, CO2, FOAM/ALCOHOL FOAM, DRY CHEMICAL.
WATER SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:AVOID WATER CONTAMINATION IN CLOSED
CONTAINER OR CONFINED AREA (CO2 EVOLVED - EXOTHERMIC).
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENTS. VENTILATE AREA.
CONTAIN SPILL, COVER LIQUID WITH ABSORBENT MATERIAL (SAW DUST, OIL
ABSORBENT, ETC.) AND PLACE IN APPROPRIATE CONTAINERS FOR LATER
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE- KEEP STORAGE CONTAINERS
SEALED OR TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:MATERIAL SLOWLY ABSORBS MOISTURE IF EXPOSED TO THE
ATMOSPHERE. WASH THOROUGHLY AFTER HANDLING. AVOID CONTACT WITH
EYES, SKIN AND CLOTHING. AVOID BREATHING VAPORS OF HEATED MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH-APPROVED RESPIRATOR WITH
APPROPRIATE ACID/GAS FILTER.
Ventilation:GOOD GENERAL VENTILATION IS SUFFICIENT FOR MOST CONDITIONS
(10 ROOM VOLUMES PER HOUR).
Other Protective Equipment:LAB APRON OR LAB COAT, EYE WASH STATION &
SAFETY SHOWER.
Work Hygienic Practices:PRACTICE GOOD HYGIENIC PROCEDURE. WASH
THOROUGHLY BEFORE EATING OR DRINKING.
Supplemental Safety and Health
THIS PRODUCT IS A KIT CONSISTING OF TWO PARTS. FOR PART A, SEE PIN A
SAME NSN. NOTE TO PHYSICIAN: ORAL TOXICITY OF THIS COMPOUND IS LOW
BUT IT IS IRRITANT. PERSONS HANDLING MATERIAL SHOULD AVOID CONTA CT
WITH THE SKIN OR EYES AND SHOULD AVOID INHALING DUST.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>585F,>307C
Spec Gravity:1.20 - 1.30
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:SLIGHTLY
Appearance and Odor:OFF WHITE OR COLOR PIGMENTED VISCOUS LIQUID - FAINT
CHARACTERISTIC ACID ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, WATER, ALCOHOLS, METAL COMPOUNDS OR SURFACE ACTIVE
AGENTS.
Stability Condition to Avoid:AVOID PROLONGED HEATING OVER 160F (71C) OR
STORAGE BELOW 80F (27C).
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, TRACES OF HYDROGEN CYANIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TT-E-2784
Preparer's Name:ONEY FLEMING
CAGE:JO954
CAGE:JO954
CAGE:39934
============= Composition/Information on Ingredients =============
Ingred Name:PROPYLENE GLYCOL
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 3.8%
Other REC Limits:NONE RECOMMENDED
Ingred Name:2,2,4-TRIMETHYL-1-3-PENTANEDIOL MONOISOBUTYRATE
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 3.51%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIMETHYLAMINOETHANOL LOW VOC
CAS:108-01-0
RTECS #:KK6125000
Fraction by Wt: 0.22%
Other REC Limits:NONE RECOMMENDED
Ingred Name:2-N-OCTYL-4-ISOTHIAZOLIN-3-ONE
CAS:26530-20-1
Fraction by Wt: 0.18%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON HAZARDOUS INGREDIENTS
Fraction by Wt: 92.29%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAN CAUSE IRRITATION OF RESPIRATORY
PASSAGES.
Effects of Overexposure:INHALATION OF VAPOR/MIST CAN CAUSE HEADACHES,
NAUSEA, IRRITATION OF NOSE/THROAT/LUNGS. EYES: CAN CAUSE SLIGHT
IRRITATION. CHRONIC SKIN CONTACT CAN CAUSE SLIGHT IRRITATION.
Medical Cond Aggravated by Exposure:PREEXISTING LUNG DISEASE MAY BE
AGGRAVATED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMTS WATER 15 MINUTES. CONSULT DR. IF
IRRITATION PERSISTS. SKIN: WASH AFFECTED AREA THOROUGHLY W/SOAP &
WATER. INGESTION: GIVE 2 GLASSES WATER. CONSULT DR.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>212F,>100C
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR SCBA (PRESSURE DEMAND MSHA/NIOSH APPROVED
OR EQUIVALENT) & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:MATERIAL CAN SPLATTER ABOVE 212F/100C.
POLYMER FILM CAN BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. FLOOR MAY BE SLIPPERY.
USE CARE TO AVOID FALLING. CONTAIN W/INERT MAT'L (SAND/EARTH).
TRANSFER LIQ/SOLID DIKING MAT'L TO SEPARATE SUITABLE CONTAINERS FOR
RECOVERY/DISPOSAL.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. DO NOT TAKE
INTERNALLY. KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED MECHANICAL FILTER RESPIRATOR TO REMOVE
SOLID AIRBORNE PARTICLES OF OVER-SPRAY DURING SPRAY APPLICATION.
Ventilation:NORMAL, SUCH AS FAN.
Other Protective Equipment:EYEWASH STATION.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212 TO 644F
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Decomp Temp:Decomp Text:350F,177C
Vapor Pres:NONE
Vapor Density:>AIR
Spec Gravity:1.13
VOC Pounds/Gallon:193
pH:9 MAX
VOC Grams/Liter:1.61
Viscosity:77-95 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:GREEN LIQUID, SLIGHT ODOR
Percent Volatiles by Volume:60.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:ACRYLIC MONOMERS
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP SPILLS/CLEANING RUN-OFF OUT OF SEWERS &
OPEN BODIES OF WATER. CONSULT FEDERAL/STATE/LOCAL AUTHORITIES FOR
PROPER DISPOSAL PROCEDURES CONCERNING HEALTH & ENVIRONMENT.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ID 0320T06M, NON YELLOWING ACTIVATOR RS1581
Kit Part:Y
Preparer's Name:LISA R. CRUZ
CAGE:98795
CAGE:98795
============= Composition/Information on Ingredients =============
Ingred Name:1,6-DIISOCYANATOHEXANE (HEXAMETHYLENE DIISOCYANATE)
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: < 10%
ACGIH TLV:0.005 PPM; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 20-30%
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC: 2.205 POUNDS PER GALLON LESS WATER
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: OVER EXPOSURE BY INHALATION MAY
CAUSE IRRITATION OF THE RESPIRATORY TRACT, HEADACHES, DIZZINESS OR
DROWSINESS. SKIN OR EYE CONTACT: IRRITANT TO THE EYES AND SKIN AND
SKIN SENSITIVITY. MAY ALSOAFFECT THE RESPIRATORY TRACT AND
CENTRAL NERVOUS SYSTEM. ALLERGIC RESPIRATORY AND SKIN REACTION.
Effects of Overexposure:ACUTE: OVER EXPOSURE BY INHALATION MAY CAUSE
IRRITATION OF THE RESPIRATORY TRACT, HEADACHES, DIZZINESS OR
DROWSINESS. SKIN OR EYE CONTACT: IRRITANT TO THE EYES AND SKIN AND
SENSITIVITY. MAY ALSO AFFEC T THE RESPIRATORY TRACT AND CENTRAL
NERVOUS SYSTEM. ALLERGIC RESPIRATORY AND SKIN REACTION.
Medical Cond Aggravated by Exposure:RESPIRATORY PROBLEMS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. EYE CONTACT: FLUSH
IMMEDIATELY WITH LARGE AMOUNTS OF RUNNING WATER FOR AT LEAST 15
MINUTES. SKIN CONTACT: REMOVE CONTAMINATED CLOTHING AND WASH SKIN
WITH SOAP AND WAT ER. INGESTION: DRINK WATER. IF NECESSARY, CONSULT
A PHYSICIAN FOR ANY OF THESE CONDITIONS.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:91 F/33 C
Lower Limits:1.70
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. VENTILATE AREA AND REMOVE WITH INERT ABSORBANT
AND NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINERS SHOULD BE GROUNDED WHEN
POURING. AVOID FREE FALL OF LIQUID IN EXCESS OF A FEW INCHES. DRUM
SHOULD BE INDUSTRIALLY CLEANED PRIOR TO REUSE.
Other Precautions:MAKE SURE THE DRUM IS COMPLETELY EMPTY BEFORE
ATTEMPTING TO WELD OR BRAZE. DO NOT FLAME CUT, BRAZE OR WELD
WITHOUT A NIOSH APPROVED RESPIRATOR OR APPROPRIATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE VAPORS OR MIST. WEAR NIOSH/MSHA
TC19C AIR LINE RESPIRATOR OR TC23C VAPOR/PARTICULATE RESPIRATOR
WHEN ISOCYANATES ARE 10 X LESS THAN TLV'S.
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST VENTILATION TO KEEP
TWA/LEL BELOW ACCEPTABLE LIMITS & TO REMOVE DECOMPOSITION PRODUCTS
Work Hygienic Practices:KEEP CONTAINERS CLOSED WHEN NOT IN USE.
Supplemental Safety and Health
DO NOT TAKE INTERNALLY.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:>259F,>126C
Vapor Density:> THAN AIR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
WATER
Stability Condition to Avoid:WILL REACT W/WATER-WATER CONTAINING
PRODUCTS TO GIVE OFF HEAT/FUMES. DON'T ALLOW WATER TO ENTER SEALED
DRUMS,MAY EXPLODE
Hazardous Decomposition Products:FUMES MAY CONTAIN CARBON MONOXIDE &
OXIDES OF NITROGEN. MAY PRODUCE HAZARDOUS FUMES WHEN HEATED TO
DECOMP AS IN WELDING.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PERMANENT GREEN INDUSTRIAL LACQUER, 70-149
CAGE:FO883
CAGE:FO883
CAGE:76708
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL; (ISOPROPANOL) (SARA III). VP:33 @ 20C.
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 9%
OSHA PEL:400 PPM;500 PPM STEL
ACGIH TLV:400 PPM;500 PPM STEL
Ingred Name:ETHANOL, 2-BUTOXY; (ETHYLENE GLYCOL MONO BUTYL ETHER).
VP:0.88 @ 25C.
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 39%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (HI-SOL)
(AROMATIC PETROLEUM DISTILLATE). VP:5 @ 100F.
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 12%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUNDS
RTECS #:9999999VO
Fraction by Wt: 624% G/L
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VENT:STATED LIM, & TO REMOVE DECOMP PRODS DURING
WELDING/FLAME CUTTING ON SURFS COATED W/THIS PRODUCT.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:ANESTHETIC. IRRIT OF RESP
TRACT/ACUTE NERV SYS DEPRESS CHARACT BY HDCH, DIZZ, STAG GAIT,
CONFUSN, UNCON/COMA. SKIN/EYE CONT:PRIMARY IRRIT. RPTD & PRLNG
OVEREXP BY INHAL/SKIN ABSORPTION MAY CAUSEKIDNEY, LIVER & BLOOD
DMG. ANIMAL STUDIES CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFTS
ON THE CNS, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:HEMATOPOIETIC TISSUES, BLOOD, KIDNEYS
& LIVER, ASSOC W/ADMIN OF ETHLENE GLYCOL MONOBUTYL ETHER (EGBE).
(EXTRACTED FROM DHHS (NIOSH) PUBLICATION NO.90-118) .
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. NOTIFY MD. EYES:FLUSH IMMEDIATELY W/COPIOUS QUANTITIES OF
RUNNING WATER FOR AT LEAST 15 MINUTES. TAKE TO MD FOR DEFINITIVE
MEDICAL TRE ATMENT. SKIN:REMOVE W/SOAP & WATER. REMOVE CONTAMINATED
CLOTHING. INGEST:DO NOT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:60.0F,15.6C
Lower Limits:2%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. DO NOT APPLY TO HOT (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES & ELECTRICAL, STATIC OR FRICTIONAL SPARKS). AVOID
BREATHING VAPORS. VENTILATE AREA. REMOVE W/INERT ABSORBENT &
NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE >120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED FOR STORAGE OF NFPA CLASS IC
FLAMMABLE LIQUIDS.
Other Precautions:DO NOT TAKE INTERNALLY. CONTAINERS SHOULD BE GROUNDED
WHEN POURING. AVOID FREE FALL OF LIQUIDS IN EXCESS OF A FEW INCHES.
DO NOT FLAME CUT, BRAZE OR WELD W/OUT NIOSH/MSHA APPROVED
RESPIRATOR OR APPROP RIATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR/OPEN AREAS, USE NIOSH/MSHA APPRVD
MECH FILTER RESP TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY
DURING SPRAY APPLICATNS. IN RESTRICTED VENT AREAS, USE NIOSH/MSHA
APPRVD CHEM-MECH FILTERS DESIGNED TO REMOVE COMBINATION (SUPDAT)
Ventilation:PROVIDE GEN DILUTION/LOC EXHST VENT IN VOL & PATTERN TO
KEEP TLV OF MOST HAZ INGS BELOW ACCEPT LIM, LEL BELOW (ING 5)
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT
W/CONTAMINATED CLOTHING.
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE EATING, SMOKING OR
USING TOILET FACILITIES.
Supplemental Safety and Health
EXPLO HAZ:SURFS. WATER SPRAY MAY BE INEFT. WATER MAY BE USED TO COOL
CLSD CNTNRS TO PVNT PRESS BUILDUP & POSS AUTOIGNIT/EXPLO WHEN EXPOS
TO EXTREME HEAT. IF WATER IS USED, FOG NOZZ ARE PREF. RESP PROT :OF
PARTICULATE & GAS & VAPS. IN CONFINED AREAS, USE NIOSH/MSHA APPRVD
AIRLINE TYPE RESPS/HOODS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>180F,>82C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.04
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:72
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:MAY PRODUCE HAZ FUMES WHEN HEATED TO
DECOMP AS IN WELDING. FUMES MAY CONTAIN CARBON MONOXIDE & OXIDE OF
NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W APPLICABLE LOCAL, COUNTY, STATE
& FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:10501 UNIVERSAL EXPOXY PART A
Kit Part:Y
CAGE:0J879
CAGE:0J879
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL A DIGLYCIDYL ETHER RESIN, EPOXY RESIN, EPON 820,
ARALDITE 6004, 4,4'-ISOPROPYLIDENEDIPHENOL-EPICHLOROHYDRIN
CAS:25068-38-6
RTECS #:KD4380000
Fraction by Wt: 50%
Ingred Name:ETHYLENE GLYCOL PROPYL ETHER, EKTASOLVE EP,
2-PROPOXYETHANOL
CAS:2807-30-9
RTECS #:KM2800000
Fraction by Wt: 10%
Ingred Name:ACETIC ACID (GLACIAL)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: <5%
OSHA PEL:25 MG/CUM
ACGIH TLV:25 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE RESPIRATORY
IRRITATION. SKIN: MAY CAUSE SENSITIZATION, ALLERGIC REACTION. EYES:
INJURY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, NAUSEA, DIZZINESS,
REDDENING, SWELLING.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED. SKIN:
WASH W/SOAP & WATER. EYES: FLUSH W/LOW PRESSURE WATER FOR 15 MINS.
REMOVE CONTACT LENSES. OBTAIN MEDICAL ATTENTION IN ALL CASES.'
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:FOR PARTIALLY EVAPORTATED MATERIAL/DRY FILM,
WEAR SELF CONTAINED BREATHING APPARATUS & FULL PROTECTIVE EQUIPMENT
WHEN ENTERING CONFINED AREA.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE. ABSORB W/INERT MATERIAL & COLLECT FOR
DISPOSAL. FLUSH AREA W/WATER. PREVENT WASHINGS FROM ENTERING
WATERWAYS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE ABOVE 40F. DON'T FREEZE. DON'T
USE IN AN ENCLOSED AREA.
Other Precautions:AVOID CONTAMINATION OF SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH APPROVED RESPIRATOR WHENEVER EXPOSURE
TO VAPOR/MIST IS LIKELY.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:SAFETY SHOWER & EYEWASH FACILITY
Work Hygienic Practices:WASH HANDS BEFORE EATING/SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-309.2F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:54
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, FREEZING.
Hazardous Decomposition Products:CO2, CO, OTHER UNKNOWN MATERIALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:176-325; 418-96; VARICHEM FIXER
CAGE:JO759
CAGE:61803
CAGE:6W820
CAGE:JO759
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 30-35%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM BISULFITE (SASA III)
CAS:7631-90-5
RTECS #:VZ2000000
Fraction by Wt: 4-8%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID (SARA III)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 4-7%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ALUMINUM SULFATE (SARA III)
CAS:10043-01-3
RTECS #:BD1700000
Fraction by Wt: 1-2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT MAY CAUSE SEVERE IRRITATION
AND BURNS TO BODY TISSUES WHICH IT CONTACTS. INHALATION OF MISTS
OR VAPORS IS HIGHLY UNLIKELY DURING ANY NORMAL USEAGE. NO CHRONIC
EFFECTS GIVEN.
Explanation of Carcinogenicity:THIS CHEMICAL IS NOT LISTED BY IARC,
NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES:SEVERE IRRITATION OR BURNS. SKIN:POSSIBLE
IRRITATION, BURNS. INHALED:UNLIKELY EXPOSURE BUT MAY CAUSE
RESPIRATORY IRRITATION IF MISTS ARE INHALED. INGESTED:SEVERE
IRRITATION OF THE DIGESTIVE TRAC T.
Medical Cond Aggravated by Exposure:NO INFORMATION GIVEN ON MSDS BY
MFR.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. EYES:IMMEDIATELY FLUSH WITH
PLENTY OF WATER FOR 15 MINUTES. GET PROMPT MEDICAL ATTENTION.
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH PLENTY OF WATER FOR 15
MINUTES. I NGESTION:DRINK MILK OR WATER. DO NOT INDUCE VOMITING.
GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:EVACUATE PERSONNEL TO A SAFE AREA. KEEP
PERSONNEL REMOVED AND UPWIND ODF FIRE. WEAR SELF-CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION , TOXIC
FUMES OF SO2 IS POSSIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROPRIATE PERSONAL PROTECTIVE EQUIPMEMT.
DIKE SPLL. PREVENT FROM ENTERING SEWERS, WATERWAYS OR LOW AREAS.
SOAK UP WITH SAND, OIL DRY OR OTHER ABSORBENT MATERIAL.
Neutralizing Agent:POWDERED SODIUM BICARBONATE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN WELL VENTILATED AREA. KEEP
CONTAINERS TIGHTLY CLOSED. DO NOT STORE WITH INCOMPATABLE
MATERIALS.
Other Precautions:DO NOT STORE OR CONSUME FOOD, DRINK OR TOBACCO IN
AREA WHERE THEY MAY BECOME CONTAMINATED WITH THIS MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO INFORMATION GIVEN ON MSDS BY MFR. SUFFICIENT
ROOM VENTILATION
Ventilation:SUFFICIENT ROOM VENTILATION
Other Protective Equipment:APRON. (SPLASH PROTECTION IS ALL THAT IS
RECOMMENDED BY MANUFACTURER.)
Work Hygienic Practices:MFR: ?HMIS:USE GOOD CHEMICAL HYGIENE
PRACTICE. AVOID UNNECESSARY CONTACT. WASH THOROUGHLY BEFORE EATING
OR DRINKING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:C3
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:AS WATER
Vapor Density:AS WATER
Spec Gravity:1.285
pH:4.85
Evaporation Rate & Reference:SAME AS WATER
Solubility in Water:100%
Appearance and Odor:CLEAR AND COLORLESS, SLIGHT SULFUR DIOXIDE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIS, OXIDIZING AGENTS
Stability Condition to Avoid:NO INFORMATION GIVEN ON MSDS BY MFR.
Hazardous Decomposition Products:OXIDES OF SULFUR AND CARBON OXIDES,
AND AMMONIA
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:RECOVER NON-USEABLE FREE LIQUID AND/OR
CONTAMINATED WATER AND DISPOSE OF IN AN APPROVED/PERMITTED
TREATMENT SYSTEM AND SOLIDS TO AN APPROVED/PERMITTED LANDFILL.
DISCHARGE TO SEWER REQUIRES APPROVAL OF PERMITTING AUTHORITY AND
MAY REQUIRE PRETREATMENT
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WET-JET
CAGE:GO210
CAGE:GO210
CAGE:0RST0
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION. INHALATION:
NASAL & RESPIRATORY IRRITATION, ASHPYXIATION. INGESTION: GI
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BLURRED VISION, REDNESS, DIZZINESS,
NAUSEA, HEADACHE, UNCONSCIOUSNESS, VOMITING, DIARRHEA.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/LARGE AMOUNTS OF
WATER. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:105F
Lower Limits:0.8
Upper Limits:7
Extinguishing Media:FOAM, CO2, DRY CHEMICALS
Fire Fighting Procedures:WEAR SCBA. WATER MAY CAUSE FROTHING, APPLY
CAUTIOUSLY.
Unusual Fire/Explosion Hazard:KEEP AWAY FROM SOURCES OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AREA. REMOVE SOURCES OF IGNITION.
VENTILATE AREA IF NECESSARY. RECOVER FREE LIQUID. ADD ABSORBENT TO
AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FORM SOURCES OF IGNITION.
USE ONLY W/ADEQUATE VENTILATION.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID PROLONGED SKIN
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV EXCEEDED, A NIOSH BREATHING APPARATUS IS
RECOMMENDED.
Ventilation:LOCAL EXHAUST/MECHANICAL (GENERAL) AS NECESSARY TO MAINTAIN
EXPOSURE < TLV LEVEL.
Other Protective Equipment:AS NECESSARY.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
GOOD STANDARD OF PERSONAL & INDUSTRIAL HYGIENE SHOULD BE MAINTAINED AT
ALL TIMES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:315F
Vapor Pres:2
Vapor Density:>1
Spec Gravity:1.1
Evaporation Rate & Reference:(BU AC = 1): <1
Solubility in Water:0
Appearance and Odor:COARSE BLACK LIQUID W/SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HEAT, SPARKS, FLAMES
Hazardous Decomposition Products:CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:THIOKOL MC-275 ACCELERATOR
Kit Part:Y
CAGE:KO006
CAGE:KO006
CAGE:0U317
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE DIOXIDE
CAS:1313-13-9
RTECS #:OP0350000
Fraction by Wt: 66.4%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:1 MG/M3/STEL 3MG/M3
Ingred Name:HYDROGENATED TERPHENYLS LD50 >10000 MG/KG ORAL RAT
CAS:61788-32-7
RTECS #:WZ6535000
Fraction by Wt: 22.7%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 PPM CEILING
ACGIH TLV:0.5 PPM
Ingred Name:TERPHENYL LD50 13200 MG/KG ORAL RAT
CAS:26140-60-3
RTECS #:WZ6450000
Fraction by Wt: 0.19%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 PPM
ACGIH TLV:0.5 PPM
Ingred Name:EXOLATED NONYL PHENYL PHOSPHATE LD50 36.30 MG/KG ORAL RAT
CAS:51811-79-1
Fraction by Wt: 2.9%
Other REC Limits:NONE RECOMMENDED
Ingred Name:1,3 DIPHENYL GUANIDINE LD50 507 MG/KG ORAL RAT LD50 290
MG/KG ORAL MOUSE
CAS:102-06-7
Fraction by Wt: 4.8%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM HYDROXIDE (CERCLA)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 0.7%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3 CEILING
ACGIH TLV:2 MG/M3 CEILING
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRIT, REDNESS, PAIN, BURNS,
CORNEAL CLOUDING, BLINDNESS CORROSIVE. SKIN: IRRIT, REDNESS, PAIN,
BLISTERS, BURNS. ABSORBED THROUGH SKIN, SENSITIZATION, CORROSIVE.
INHAL: IRRIT TO MUCOUS MEMBRANE, COUGHING, BREATHING DIFFICULT,
CORROSIVE. INGEST: GI IRRIT, NAUSEA, VOMITING & GI UPSET, ABDOMINAL
PAIN, FEVER, LIVER *
Effects of Overexposure:* KIDNEY DAMAGE, EYE, SKIN IMMUNE SYSTEM AND
ALLERGIC REACTION. HEADACHE, NAUSEA, DIARRHEA, ANEMIA, BURNS TO
MOUTH/THROAT PULMONARY EDEMA.
Medical Cond Aggravated by Exposure:LIVER/KIDNEY, SKIN, IMMUNE, SYSTEM,
CHEMICAL ALLERGIES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINUTES, LIFT LIDS. GET MED AID.
SKIN: WASH W/SOAP & WATER. REMOVE CONTAM CLOTHES/SHOES, WASH BEFORE
REUSE. INHAL: REMOVE TO FRESH AIR, GET MED AID. ARTIF RESP/CPR IF
BREATH ING DIFFICULT. INGEST: INDUCE VOMITING W/SYRUP OF IPECAC,
DRINK 2 GLASSES WATER OR STICK FINGER DOWN THROAT. DONT GIVE
ANYTHING BY MOUTH TO UNCONSCIOUS PERSON. GET MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F,>93C
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:SM FIRES: DRY CHEMICAL, CARBON DIOXIDE, HALON,
WATER SPRAY OR FOAM. LG FIRE: WATER SPRAY, FOG OR ALCOHOL FOAM.
Fire Fighting Procedures:NIOSH APPROVED POSITIVE PRESSURE SCBA & FULL
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SHOVEL/VACUUM SPILLED PRODUCT. PLACE IN CLOSED
CONTAINER. DO NOT FLUSH TO STREAMS/SEWERS/ANY BODIES OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY WELL VENTED AREA.
EMPTY CONTAINERS MAY RETAIN PRODUCT RESIDUE DO NOT REUSE CONTAINER.
Other Precautions:IF AIRBORNE CONCENTRATIONS EXCEED EXPOSURE LIMITS,
EVAC & VENTILATE AREA. USE AIR SUPPLIED RESPIRATOR/SCBA IN
INADEQUATELY VENTED AREAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED EQUIPMENT. USE
SCBA/SUPPLIED AIR RESPIRATOR. COMPLY W/29CFR1910.134.
Ventilation:LOCAL EXHAUST RECOMMENDED TO MAINTAIN AIRBORNE
CONCENTRATIONS BELOW LIMITS. GENERAL DILUTION ACCEPTABLE.
Other Protective Equipment:EYEWASH FACILITY, PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING/SMOKING/DRINKING/USING RESTROOM FACILITIES.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NA
Vapor Pres:0.1 @ 25C
Vapor Density:>1.0
Spec Gravity:2.1 WATER = 1
pH:NA
Evaporation Rate & Reference:>1.0
Solubility in Water:NA
Appearance and Odor:BLACK PASTE, PHENYL ODOR.
Percent Volatiles by Volume:NA
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, NICKEL, COBALT, IRON OR COPPER.
Hazardous Decomposition Products:AMINES, SMOKE, SOOT AND TOXIC FUMES,
OXIDES OF CARBON & METAL OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF DISCARDED IN UNUSED FORM, DISPOSE OF AT
LICENSED FACILITY ACCORDING TO FEDERAL, STATE AND LOCAL
REGULATIONS. CONTACT EPA IF NEEDED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SCHEDULE 7 CHAMBER CLEANER, 511842
CAGE:FO738
CAGE:32510
CAGE:FO738
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHORIC ACID (SARA 313) (CERCLA)
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: >15%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/3 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CITRIC ACID
CAS:77-92-9
RTECS #:GE7350000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYOXYPROPYLENE GLYCOL; (POLYPROPOXYETHANOL)
CAS:9003-11-6
RTECS #:MD0911050
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CORROSIVE. CAUSES SEVERE BURNS
TO SKIN AND EYES. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:OPEN CUTS AND SORES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/FLOWING WATER FOR AT LEAST 15 MINUTES & SEE MD.
SKIN: FLUSH W/FLOWING WATER FOR 15 MINUTES. SEE MD IF IRRITATION
PERSISTS. INGESTION: GIVE MILK/WATER TO DILUTE MATERIAL & DO NOT
INDUCE V OMITING. SEE MD IMMED. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. INHALATION: REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY OR FOG, CARBON DIOXIDE IF PRODUCT IS
INVOLVED.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID EXPOSURE TO FUMES OR VAPORS.
Unusual Fire/Explosion Hazard:USE WATER SPRAY TO COOL ADJACENT
FIRE-EXPOS CONTRS. MAY GENERATE HYDROGEN GAS IF IN CONT W/SOME
METALS. PROD WILL NOT BURN BUT MAY SPLATTER IF TEMP EXCEEDS BP.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP AND FLUSH TO SEWER WITH PLENTY OF
WATER. FLOORS MAY BE SLIPPERY. USE CARE TO AVOID FALLS.
Neutralizing Agent:NEUTRALIZE WITH SODIUM BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. DO NOT
CONTAMINATE WATER, FOOD OR FEED. AVOID ALL CONTACT.
Other Precautions:DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. AVOID
BREATHING OF VAPOR OR SPRAY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST: PREFERRED. MECHANICAL (GENERAL) VENTILATION:
ACCEPTABLE.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . IMPERVIOUS RUBBER BOOTS AND APRON.
Work Hygienic Practices:REMOVE & WASH CONTAM CLTHG BEFORE REUSE.
PRACTICE GOOD PERS HYGIENE. WASH AFTER HANDLING. SHOWER AT END OF
WORK PERIOD.
Supplemental Safety and Health
PH: 1.0 (CONCENTRATE); 3.0 (USE DILUTION).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:17
Vapor Density:0.62
Spec Gravity:1.0936 (H*2O=1)
pH:SUPDAT
Evaporation Rate & Reference:1.0 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS THIN LIQUID, WITH CHARACTERISTIC
ACID ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:STORE IN A COOL, DRY AREA.
Hazardous Decomposition Products:HYDROGEN GAS IN CONTACT WITH SOME
METALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS. SELL FOR SALVAGE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2085 BROMTHYMOL BLUE INDICATOR
Preparer's Name:STEPHEN M BACON
CAGE:EO526
CAGE:EO526
CAGE:89975
============= Composition/Information on Ingredients =============
Ingred Name:BROMOTHYMOL BLUE, SODIUM SALT
CAS:76-59-5
RTECS #:SJ7450000
Ingred Name:SODIUM HYDROXIDE, CAUSTIC SODA, LYE
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: <1%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/CUM
ACGIH TLV:2 MG/CUM CEILING
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: <100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT W/SKIN MAY CAUSE STAINING &
IRRITATION. EYE CONTACT CAUSES IRRITATION. INGESTION MAY CAUSE GI
DISTURBANCE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:CONTACT W/SKIN MAY CAUSE STAINING & IRRITATION.
CONTACT W/EYES CAUSES IRRITATION. INGESTION MAY CAUSE GI
DISTURBANCE.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/WATER FOR 15 MINS.
INGESTION: GIVE PLENTY OF WATER. INDUCE VOMITING UNDER DIRECTION OF
PHYSICIAN. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:USE SELF CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: FLUSH TO SEWER, IF DESIRED, ABSORB
W/VERMICULITE/OTHER INERT MATERIAL/CONTAINERIZE FOR LATER DISPOSAL.
LARGE: ABSORB W/VERMICULITE/OTHER MATERIAL, & CONTAINERIZE FOR
DISPOSAL.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:LAB COAT
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:17
Vapor Density:0.6
Spec Gravity:1
pH:6.8
Solubility in Water:COMPLETE
Appearance and Odor:DARK GREEN, WATERLIKE SOLUTION
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CARBON OXIDES, SULFUR OXIDES & BROMINE
FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE/DISPOSE OF IAW/LOCAL STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CWO-1180 CODET BLUE
CAGE:09800
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <8%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:2-PROPANOL, 1-METHOXY-; (PROPYLENE GLYCOL) LEL:2.6%
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: <5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER WITH
2,2,4-TRIMETHYL-1,3-PENTANEDIOL; (ESTER ALCOHOL)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IN A CONFINED AREA VAPORS IN HIGH
CONCENTRATION ARE ANESTHETIC. IRRITANT TO SKIN AND UPPER
RESPIRATORY SYSTEM. OVER-EXPOSURE MAY RESULT IN LIGHT-HEADEDNESS,
STAGGERING GAIT, GIDDINESS AND POSSIBLE NAU SEA. CONTAINS PETROLEUM
DISTILLATES-HARMFUL OR FATAL IF SWALLOWED. CHRONIC:REPORTS HAVE
ASSOCIATED (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:REPEATED AND PROLONGED OVEREXPOSURE
TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. ALSO
KIDNEY AND LIVER DAMAGE.
Medical Cond Aggravated by Exposure:NONE ESTABLISHED.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE PATIENT TO FRESH AIR. EYES:FLUSH WITH WATER
FOR AT LEAST 15 MINUTES. SKIN:WASH WITH SOAP AND WATER.
INGESTION:CALL PHYSICIAN IMMEDIATELY. DO NOT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Lower Limits:SEE INGS
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER MAY BE INEFFECTIVE. WATER MAY BE USED
TO KEEP FIRE EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:DO NOT SPRAY NEAR OPEN FLAME. KEEP AT
ROOM TEMPERATURE AS EXPOSURE TO DIRECT SUNLIGHT OR OTHER HEAT MAY
CAUSE BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE,
AVOID BREATHING VAPORS AND REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. KEEP AT ROOM
TEMPERATURE. EXPOSURE TO DIRECT SUNLIGHT OR HEAT MAY CAUSE
BURSTING.
Other Precautions:KEEP AWAY FROM CHILDREN. DO NOT PUNCTURE OR
INCINERATE. DO NOT SPRAY NEAR FIRE OR OPEN FLAME. AVOID BREATHING
OF VAPOR OR SPRAY MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMS BY VENT, WEAR PROPERLY FITTED NIOSH/MSHA APPRVD ORG
VAP/PARTICULATE RESP FOR PROT AGAINST MATLS IN INGS. WHEN
SANDING/ABRADING DRIED FILM, WEAR NIO SH/MSHA APPRVD DUST/MIST RESP
(SUP DAT)
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
RESP PROT:FOR DUST WHICH MAY BE GENERATED FROM THIS PROD, UNDERLYING
PAINT/THE ABRASIVE. APPLIC LIMS FOR NUISANCE DUSTS ARE ACGIH TLV
10MG/M3 (TOTAL DUST), OSHA PEL 15MG/M3 (TOTAL DUST), 5MG/M3 (RESP
PROT AGAINST MATLS IN INGS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:0F,-18C
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:COATINGS
Percent Volatiles by Volume:2 (WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:DO NOT STORE ABOVE 120F.
Hazardous Decomposition Products:BY OPEN FLAME:CARBON MONOXIDE, CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE. DISPOSE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL ALKYD GLOS LOW VOC CONTENT YEL 13655
Preparer's Name:FRED ARMSTRONG
CAGE:33832
CAGE:33832
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 17.5%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:SUPER HIFLASH NAPTHA, PETROLEUM SOLVENT
CAS:64742-95-6
Fraction by Wt: 7%
OSHA PEL:200 PPM
ACGIH TLV:100 PPM
Ingred Name:PM ACETATE, (ESTER SOLVENT)
CAS:108-65-6
RTECS #:AI8295000
Fraction by Wt: 9%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:MAX VOC AFTER THINNING=408 GRAMS/LITER OR 3.4 LBS/GAL
VOC=360 GRAMS/LITER OR 3.0 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Health Hazards Acute and Chronic:OVEREXPOSURE-NAUSEA, HEADACHE,
DIZZINESS CAUSED BY OVER INHALATION.
Effects of Overexposure:OVEREXPOSURE-NAUSEA, HEADACHE, DIZZINESS CAUSED
BY OVER INHALATION. HIGH VAPOR CONCENTRATIONS (>1000 PPM) ARE
IRRITATING TO THE EYES & RESPIRATORY TRACT, ARE ANESTHETIC & MAY
HAVE OTHER CENTRAL NERVOU S SYSTEM EFFECTS.
Medical Cond Aggravated by Exposure:NONE GENERALLY KNOWN.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH WITH WATER 15 MINUTES OR UNTIL IRRITATION
SUBSIDES. IF IRRITATION PERSISTS, CALL PHYSICIAN. SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING & WASH THOROUGHLY WITH SOAP & WATER.
INHALATIO N: IF OVERCOME BY VAPORS, REMOVE TO FRESH AIR, CALL A
PHYSICIAN. INGESTION: DO NOT INDUCE VOMITING, CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:103 F/40 C
Autoignition Temp:Autoignition Temp Text:473 F
Lower Limits:0.7
Upper Limits:13.1
Extinguishing Media:CARBON DIOXIDE, FOAM, WATER FOG, DRY CHEMICAL.
Fire Fighting Procedures:USE AIR SUPPLIED BREATHING EQUIPMENT. COOL
ENCLOSED CONTAINERS WITH WATER SPRAY. AVOID BREATHING VAPORS OR
FUMES.
Unusual Fire/Explosion Hazard:IF LEAK OR SPILL HAS IGNITED, USE WATER
SPRAY TO DISPERSE THE VAPORS FROM FIRE FIGHTERS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. KEEP FROM HEAT,
SPARKS & OPEN FLAME. ADD ABSORBENT (SAND, EARTH, SAWDUST) TO SPILL.
VENTILATE AREA (OPEN WINDOWS, DOORS). LARGE SPILL: KEEP FROM
ENTERING SEWERS & WATERCOU RSES BY DIKING. ADVISE AUTHORITIES IF
DOES ENTER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM IGNITION SOURCES. KEEP
IN COOL, DRY, WELL VENTILATED AREAS. AVOID DIRECT SUNLIGHT &
EXTREME TEMPERATURES, HOT OR COLD.
Other Precautions:AVOID EYE &/OR SKIN CONTACT. INHALATION &/OR
INGESTION OF MISTS, SPRAY OR VAPORS. AVOID BREATHING SANDING OR
BLASTING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE HYDROCARBON VAPOR CANISTER OR SUPPLIED AIR
RESPIRATOR IN CONFINED AREAS.
Ventilation:LOCAL EXHAUST: FACE VELOCITY 60FPM. SPECIAL: USE ONLY WITH
ADEQUATE VENTILATION. MECHANICAL: EXPLOSION PROOF EQUIPMENT.
Other Protective Equipment:USE CHEMICAL RESISTANT APRON OR CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:308 F/155 C
Melt/Freeze Pt:M.P/F.P Text:O F(-17.8C)
Decomp Temp:Decomp Text:600 F/316 C
Vapor Pres:<10 @ 68 F
Vapor Density:4.8 @ 77 F
Spec Gravity:1.07 (H2O=1)
Viscosity:70-85@77FKREB
Evaporation Rate & Reference:0.09 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW LIQUID WITH KEROSENE ODOR.
Percent Volatiles by Volume:44.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAN REACT WITH OXIDIZING MATERIAL WHEN HEATED TO DECOMPOSITION.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:ASSURE CONFORMITY WITH APPLICABLE DISPOSAL
REGULATIONS. DISPOSE OF ABSORBED MATERIAL AT AN APPROVED DISPOSAL
SITE OR FACILITY. DISPOSE IN CONFORMITY WITH STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MOORES UNIVERSAL TINTING COLORS,WHITE
CAGE:09585
CAGE:09585
CAGE:91950
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 36%
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:INGESTION HAZARD CAUSING NARCOSIS & SERIOUS
KIDNEY DAMAGE FROM ETHYLENE GLYCOL. EYES: PRIMARY IRRIT.
======================= First Aid Measures =======================
First Aid:INGEST: IMMED GIVE 1 OR 2 GLASSES OF H*2O & CALL PHYS,HOSP
EMERGENCY ROOM,OR POISON CONTROL FOR WAY TO INDUCE VOMITING. EYES:
FLUSH W/H*2O AT LEAST 15 MIN. IF IRRIT PERSISTS,CONSULT PHYSICIAN.
SKIN: W ASH OFF W/SOAP & H*2O.
===================== Fire Fighting Measures =====================
Flash Point:>200F
Lower Limits:3.2
Extinguishing Media:ALCOHOL FOAM,DRY CHEMICAL,CO*2
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER,ABSORB W/FULLERS EARTH.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED CONTACT W/SKIN & EYES.
CONTAINS ETHYLENE GLYCOL- DO NOT TAKE INTERNALLY- HARMFUL OR FATAL
IF SWALLOWED.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. CLOSE CONTAINER AFTER
EACH USE. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED FOR NON-CONFINED USE.
Ventilation:NORMAL,AVOID OVEREXPOSURE IN CONFINED AREAS.
Other Protective Equipment:EYE BATH
Supplemental Safety and Health
VAPOR PRESSURE: (ETHYLENE GLYCOL) 0.05 MMHG @ 68F.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-400F
Vapor Density:>1
Spec Gravity:1.72
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:56
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE CO &
CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONVENTIONAL METHODS. WASTE DISPOSAL MUST BE IN
ACCD W/FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
Subsets and Splits
No saved queries yet
Save your SQL queries to embed, download, and access them later. Queries will appear here once saved.