text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:NEW YORK FLOORING UNDERLAYMENT POWDER
CAGE:HO239
CAGE:HO239
CAGE:73820
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 65%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:PORTLAND CEMENT
CAS:65997-15-1
RTECS #:VV8770000
Fraction by Wt: 35%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Effects of Overexposure:INJURIOUS TO EYES & CAUSES SKIN IRRIT. INHAL OF
DUST MAY LEAD TO IRRIT OF RESP TRACT. (SEE SUPP DATA
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/LOW PRESSURE H*2O 15 MIN & CALL PHYS. INGEST:
PATIENT CONSCIOUS,FIRST GIVE LRG AMTS H*2O/MILK,THEN INDUCE VOMIT
BY TOUCH BACK OF THROAT W/FINGER. CALL PHYS IMMED. SKIN: WASH
W/SOAP & H*2O . IF IRRIT PERSISTS,CALL A PHYS. (SEE SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point:N/A (PMCC)
Extinguishing Media:NOT COMBUSTIBLE
Fire Fighting Procedures:NOT COMBUSTIBLE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP,BUT AVOID CREATING EXCESSIVE DUST.
======================Handling and Storage ======================
Handling and Storage Precautions:HIGH HUMIDITY OR WATER WILL HARDEN
POWDER DURING STORAGE. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD RESPIRATOR MASK W/REPLACEABLE
DUST FILTER.
Ventilation:LOCAL EXHAUST- POSITIVE VENTILATION
Supplemental Safety and Health
EFFECTS OF OVEREXP: INGEST MAY RESULT IN OBSTRUCTION. EMER FIRST AID
PROC: IF AFFECTED BY INHALATION REMOVE TO FRESH AIR.
================== Physical/Chemical Properties ==================
Spec Gravity:2.8
Solubility in Water:SLIGHT
Appearance and Odor:GRAY POWDER,ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:TO LANDFILL,MAY PLUG DRAINS. WASTE DISPOSAL MUST
BE IAW FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SODIUM CARBONATE, ANHYDROUS, 5151
CAGE:JO749
CAGE:JO749
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CARBONATE (2:1); (SODIUM CARBONATE, ANHYDROUS).
LD50: (ORAL, RAT) 5600 MG/KG.
CAS:497-19-8
RTECS #:VZ4050000
Fraction by Wt: 99-100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF UPPER
RESPIRATORY TRACT, IRRITATION OF MUCOUS MEMBRANES. SKIN CONTACT:
IRRITATION. EYE CONTACT: IRRITATION. SKIN ABSORPTION: NONE
IDENTIFIED. INGESTION: INGESTION OF LARGE QU ANTITIES MAY CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, DIARRHEA. CHRONIC
EFFECTS: NONE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: IDENTIFIED. TARGET ORGANS: NONE
IDENTIFIED.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:INGESTION: IF SWALLOWED AND THE PERSON IS CONSCIOUS,
IMMEDIATELY GIVE LARGE AMOUNTS OF WATER. GET MEDICAL ATTENTION.
INHALATION: IF A PERSON BREATHES IN LARGE AMOUNTS, MOVE THE EXPOSED
PERSON TO FRESH AIR. SKIN CONTACT: IN CASE OF CONTACT,IMMEDIATELY
WASH SKIN W/PLENTY OF SOAP AND WATER FOR AT LEAST 15 MINUTES. EYES:
IN CASE OF CONTACT, IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT
LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE IDENTIFIED. TOXIC GASES PRODUCED:
CARBON MONOXIDE, CARBON DIOXIDE, SODIUM PEROXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROTECTIVE CLOTHING. CAREFULLY
SWEEP UP AND REMOVE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA. MAY BE HARMFUL IF
SWALLOWED. MAY CAUSE IRRITATION. HYGROSCOPIC.
Other Precautions:AVOID SIMULTANEOUS PRESENCE OF SODA ASH AND LIME
DUST; THE COMBINATION IN THE PRESENCE OF PERSPIRATION OR MOISTURE
WILL CAUSE FORMATION OF IRRITATING CAUSTIC SODA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, USE AN
APPROPRIATE NIOSH APPROVED RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
LAB COAT:Work Hygienic Practices:DURING USE AVOID CONTACT
WITH EYES, SKIN, CLOTHING. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1564F,851C
Spec Gravity:2.53 (H*2O=1)
Solubility in Water:APPRECIABLE (>10%)
Appearance and Odor:WHITE TO GRAY CRYSTALS; ODORLESS.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ALUMINUM, FLUORINE, OXIDES OF PHOSPHORUS, LITHIUM.
Stability Condition to Avoid:HUMIDITY.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SODIUM PEROXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:POTASSIUM PERMANGANATE, 19520, P287 500
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:PERMANGANIC ACID, POTASSIUM SALT (SARA 313) (CERCLA).
LD50:(ORAL,RT) 1090 MG/KG.
CAS:7722-64-7
RTECS #:SD6475000
Fraction by Wt: 100%
OSHA PEL:5 MG/M3, C (MN)
ACGIH TLV:5 MG/M3 (MN)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SUPP DATA:INHAL:GET MED AID IMMED. REMOVE FROM EXPOS TO
FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:IS DIFFICULT, GIVE OXYGEN. NOTES TO MD:TREAT
SYMPTOMATICALLY & SUPPORTIVELY. ANTIDOTE:NONE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:CONTACT MAY CAUSE SEVERE
IRRITATION AND POSSIBLE BURNS. SKIN:EXPOSURE MAY CAUSE IRRITATION
AND POSSIBLE BURNS. CONTACT CAN CAUSE BROWN STAINS IN AREA AND
POSSIBLE HARDENING OF OUTER SKIN LAY ER. INGESTION:HARMFUL IF
SWALLOWED. MAYCAUSE KIDNEY DAMAGE. MAY CAUSE SEVERE
GASTROINTESTINAL TRACT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:IRRITATION WITH NAUSEA, VOMITING AND
POSSIBLE BURNS. INHALATION:CAUSES RESPIRATORY TRACT IRRITATION.
CHRONIC:PROLONGED OR REPEATED CONTACT MAY CAUSE DEFATTING AND
DERMATITIS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS, OCCAS
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW VICTIM
TO RUB/KEEP EYES CLSD. SKIN:GET MED AID IMMED. IMMED FLUSH W/PLENTY
OF S OAP & WATER FOR AT LST 15 MINS WHILE REMOVING CONTAM CLTHG &
SHOES. INGEST:DO NOT INDUCE VOMIT. IF VICTIM IS CONSCIOUS & ALERT,
GIVE 2-4 CUPFULS OF MILK/WATER. NEVER GIVE ANYTHING BY MOUTH TO
(SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:FOR SMALL FIRES, USE DRY CHEMICAL, CARBON DIOXIDE,
WATER SPRAY OR ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:STRONG OXIDIZER. CONTACT W/COMBUSTIBLE
MATERIALS MAY CAUSE A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT AS
INDICATED IN EXPOSURE CONTROLS, PERSONAL PROTECTION SECTION. VACUUM
OR SWEEP UP MATERIAL & PLACE INTO A SUITABLE DISPOSAL CONTAINER.
AVOID GENERATING DUSTY CONDITIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE W/ADEQ VENT. DO NOT GET IN EYES,
ON SKIN/ON CLTHG. KEEP CNTNR TIGHTLY CLSD. AVOID CONT W/CLTHG &
OTHER COMBUST MATLS. DO NOT INGEST/INHALE. FLAMM.
Other Precautions:KEEP AWAY FROM SOURCES OF IGNIT. DO NOT STORE NEAR
COMBUST MATLS. STORE IN TIGHTLY CLSD CNTNR. STORE IN COOL, DRY,
WELL-VENTED AREA AWAY FROM INCOMPAT SUBSTANCES. KEEP OUT OF REACH
OF CHILDREN. IN CAS E OF ACCIDENT/IF YOU FEEL (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW OSHA RESPIRATOR REGULATIONS FOUND IN 29
CFR 1910.134. ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE VENTILATION TO KEEP AIRBORNE CONCENTRATIONS
LOW.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR APPROP PROT CLTHG TO PREVENT SKIN
EXPOS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MATLS TO AVOID:DIMETHYLFORMAMIDE. FORMS SENSITIVE EXPLO MIXTS
W/AMMONIUM PERCHLORATE, TITANIUM, ARSENIC, PHOSPHORUS, SING WOOL &
SULFUR. REACT W/REDUCING AGENTS. OTHER PREC:UNWELL, SEEK MED ADVICE
IMM ED (SHOW LBL WHERE POSS). EYE PROT:& FULL LGTH FSHLD . FIRST
AID PROC:AN UNCON PERS. GET MED AID IMMED. (ING 2)
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:464F,240C
Spec Gravity:2.703
Solubility in Water:MODERATELY SOLUBLE
Appearance and Odor:DARK PURPLE SOLID; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EXPLODES ON CONT W/SOME ACIDS SUCH AS ACETIC ACID, CONC HYDROCHLORIC
ACID & FORMALDEHYDE, AMMONIUM NITRATE, (SUPP DATA)
Stability Condition to Avoid:HIGH TEMPERATURES, INCOMPATIBLE MATERIALS,
COMBUSTIBLE MATERIALS, REDUCING AGENTS.
Hazardous Decomposition Products:OXIDES OF POTASSIUM.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT W/FEDERAL,
STATE & LOCAL REGULATIONS. NOT LISTED AS A MATERIAL BANNED FROM
LAND DISPOSAL ACCORDING TO RCRA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FUEL NAVAL DISTILLATE (F76)
CAGE:KO891
CAGE:52838
CAGE:0KST4
CAGE:KO891
============= Composition/Information on Ingredients =============
Ingred Name:DIESEL FUEL
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 OIL MIST
ACGIH TLV:5 MG/M3 OIL MIST
Ingred Name:ADDITIVES: KEROFLUX II
Other REC Limits:1000 PPM (MFR)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MODERATE SKIN IRRITATION.
INHALATION MAY CAUSE IRRITATION TO NOSE, THROAT AND LUNGS, CENTRAL
NERVOUS SYSTEM EFFECTS. ASPIRATION OF OIL INTO LUNGS AFTER
INGESTION MAY CAUSE PNEUMONITIS. CHRONIC: EYE AND SKIN IRRITATION,
DERMATITIS.
Explanation of Carcinogenicity:MANUFACTURER DID NOT INDICATE THE
PRESENCE OF CARCINOGENS IN THIS PRODUCT.
Effects of Overexposure:HEADACHE, DIZZINESS, NAUSEA, VOMITING, LOSS OF
COORDINATION, RASH OF ACNE, PIMPLES AND SPOTS (USUALLY ON ARMS AND
LEGS).
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH A HISTORY OF SKIN
AND RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. IF
IRRITATION PERSISTS, SEE DOCTOR. SKIN: WIPE EXCESS OIL OFF WITH A
DRY CLOTH. WASH WITH SOAP AND WATER WHILE REMOVING CONTAMINATED
CLOTHING AND SHOES. INHALATION: REMOVE VICTIM TOFRESH AIR. GIVE
OXYGEN/CPR IF NEEDED. SEE DOCTOR. INGESTION: DO NOT INDUCE
VOMITING. SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:131F,55C
Lower Limits:6
Upper Limits:13.5
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. COOL FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:MODERATELY COMBUSTIBLE. IT CAN BURN IN
THE OPEN OR BE EXPLOSIVE IN CONFINED SPACES. MISTS OR SPRAYS MAY BE
FLAMMABLE AT TEMPERATURES BELOW THE FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE PERSONNEL. ELIMINATE IGNITION SOURCES.
VENTILATE AREA. WEAR PROTECTIVE CLOTHING AND EQUIPMENT. ABSORB IN
INERT MATERIAL AND PLACE IN APPROPIATE DISPOSAL CONTAINER AND
COVER. WASH AREA WITH PLEN TY OF SOAP AND WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:SPECIAL SLOW LOAD PROCEDURES FOR
"SWICH LOADING" MUST BE FOLLOWED TO AVOID STATIC IGNITION HAZARD.
KEEP CONTAINERS CLOSED AND AWAY FROM HEAT/IGNITION.
Other Precautions:PROTECT CONTAINERS FROM PHYSICAL DAMAGE. USE
NON-SPARKING TOOLS AND EXPLOSION-PROOF EQUIPMENT. PREVENT STATIC
ELECTRIC SPARKS. NO SMOKING IN AREAS OF USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. NIOSH/MSHA-APPROVED
RESPIRATOR OR SCBA AS APPROPIATE FOR EXPOSURE OF CONCERN.
Ventilation:EXPLOSION-PROOF MECHANICAL (GENERAL) VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO MINIMIZE
EXPOSURE FROM PROLONGED OR REPEATED CONTACT. EYE BATH AND SAFETY
SHOWER.
Work Hygienic Practices:DO NOT WEAR OIL CONTAMINATED CLOTHING. DO NOT
PUT OILY RAGS INTO POCKETS. WASH AFTER HANDLING AND BEFORE EATING.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:360F,182C
Melt/Freeze Pt:M.P/F.P Text:-4F,-20C
Vapor Pres:NEGLIGIBLE
Vapor Density:>1
Spec Gravity:0.84
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, VISCOUS AND YELLOW LIQUID. MILD HYDROCARBON
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS. MAXIMIZE PRODUCT RECOVERY FOR RESUSE OR RECYCLING.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:83341 SAFFIL ALUMINA FIBER
CAGE:70657
CAGE:70657
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE, BAUXITE, ALUMINA, DIALUMINUM TRIOXIDE
*98-2*
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: >95%
OSHA PEL:15 MG/CUM TOTAL DUST
ACGIH TLV:10 MG/CUM TOTAL DUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): >5,000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: MILDLY
IRRITATING. INHALATION: IRRITATION OF MUCOUS MEMBRANES OF THE UPPER
RESPIRATORY TRACT MAY DEVELOP.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN: WASH OFF W/PLENTY OF SOAP & WATER. EYES: FLUSH W/PLENTY
OF WATER & CONTINUE FLUSHING FOR 15 MINS. INGESTION: GIVE 1/2
GLASSES OF WATER TO DRINK. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PE RSON. INHALATION: REMOVE TO FRESH AIR. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE SCBA W/FULL FACEPIECE & PROTECTIVE
CLOTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RESPIRATORY PROTECTION DURING CLEANUP.
SWEEP UP & RECOVER/MIX MATERIAL W/A MOIST ABSORBENT & SHOVEL INTO A
CHEMICAL WASTE CONTAINER. WASH RESIDUE W/WATER CONTAINING DETERGENT
& FLUSH TO A SEWER S ERVICED BY A WASTEWATER TREATMENT FACILITY.
======================Handling and Storage ======================
Other Precautions:AVOID BREATHING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF NEEDED, USE MSHA/NIOSH APPROVED RESPIRATOR
FOR DUSTS, MISTS & FUMES WHOSE TLV IS GREATER THAN 0.05 MG/CUM.
Ventilation:LOCAL EXHAUST TO MINIMIZE EXPOSURES.
Other Protective Equipment:IMPERVIOUS APRON, LOOSE FITTING CLOTHES
W/LONG SLEEVES, EYE WASH STATION.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>3632F
Spec Gravity:3.3
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE ODORLESS FIBERS
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARDED PRODUCT ISN'T A HAZARDOUS WASTE UNDER
RCRA. DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VERSI-FOAM SYSTEMS 15, 50 REFILLABLES- (SUP
CAGE:RHHFO
CAGE:RHHFO
============= Composition/Information on Ingredients =============
Ingred Name:POLYETHER POLYOL; (POLYETHER POLYOL RESIN)
CAS:37208-53-0
Fraction by Wt: 49%
Ingred Name:2-PROPANOL, 1,3-DICHLORO-,PHOSPHATE(3:1); (HALOGENATED
PHOSPHATE ESTER)
CAS:13674-87-8
RTECS #:UB1473000
Fraction by Wt: 12%
Ingred Name:DICHLORODIFLUOROMETHANE (SARA III)
CAS:75-71-8
RTECS #:PA8200000
Fraction by Wt: 16%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
Ingred Name:TRICHLOROFLUOROMETHANE (CFC-11) (SARA III)
CAS:75-69-4
RTECS #:PB6125000
Fraction by Wt: 20%
OSHA PEL:1000 PPM
ACGIH TLV:C, 1000 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
Ingred Name:; (SILICONE SURFACTANT)
CAS:68937-54-2
Fraction by Wt: <1%
Ingred Name:AMINE CATALYST
Fraction by Wt: <1%
Ingred Name:ORGANOTIN CATALYST
Fraction by Wt: <1%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE ANTIC UNLESS FLUOROCARBON
VAP/CONC EXCEEDS 10%. MAY IRRIT SKIN/EYES UPON CONT.
CHLOROFLUOROCARBON MATLS HAVE PRDCED SENSIT OF THE MYOCARDIUM TO
EPINEPHRINE IN LAB ANIMALS & MAY HAVE A SIMILAR EFT IN HUMANS.
ADRENOMIMETICS (E.G.,EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR
LIFE-SUSTAINING USES IN HUMANS (SUPDAT)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:IRRITATION OF MUCUOUS MEMBRANE, TIGHTNESS OF
CHEST. IRRITATION OF RESPIRATORY TRACT, COUGHING, HEADACHE,
SHORTNESS OF BREATH. IRRITATION OF SKIN AND EYES.
Medical Cond Aggravated by Exposure:BRONCHIAL, RESPIRATORY &/OR
ALLERGENIC CONDITIONS.
======================= First Aid Measures =======================
First Aid:SKIN: FLUSH W/WATER. EYES: FLUSH W/WATER FOR A MINIMUM OF 15
MIN. CONSULT MD. INHAL: REMOVE FROM CONTAMINATED AREA TO FRESH AIR.
CONTACT MD. ADMINISTER OXYGEN IF NECESSARY. INGEST: CALL MD
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL, FOAM OR WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTAINS CCL2 AND N2 WHICH CAN DEVELOP
PRESSURE IN SEALED CONTAINER. THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE CHLORIDES, FLUORIDES & PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA AND CONTAIN SPILL IF POSSIBLE.
ABSORB IN ABSORBANT SWEEPING COMPOUND, REMOVE IN OPEN DRUMS AND
FLUSH AREA WITH WATER AND DETERGENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BODY CONTACT AND INHALATION OF
VAPORS. STORE ONLY IN HIGH PRESSURE CONTAINERS IN COOL, DRY AREA.
KEEP FROM FREEZING.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR
UV RADIATION MAY CAUSE THE FORMATION OF CHLORIDES, FLUORIDES AND/OR
PHOSGENE (FP N).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED AIR SUPPLIED FACE MASK IS
RECOMMENDED FOR HIGH VAPOR PRESSURE.
Ventilation:LOCAL EXHAUST TO MAINTAIN VAPOR CONCENTRATION BELOW TLV.
Other Protective Equipment:IN WORK AREAS OF HIGH EXPOSURE POTENTIAL,
PROVIDE SAFETY SHOWERS AND EYE WASH STATIONS.
Work Hygienic Practices:STANDARD INDUSTRIAL PRACTICES.
Supplemental Safety and Health
MFR'S PART NO/TRADE NAME: 2 STANDARD, SLO RISE. HAZ DECOMP PROD:
FLUORIDES AND PHOSGENE . HLTH HAZ: ACUTELY OR CHRONICALLY EXPOSED
TO CHLOROFLUOROCARBONS .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-22F,-30C
Vapor Pres:<70 PSIG
Vapor Density:4.74
Spec Gravity:1.21
Solubility in Water:PARTIALLY SOLUBLE
Appearance and Odor:AMBER LIQUID WITH ETHEREAL COLOR.
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
UNCONTROLLED MIXTURE WITH ISOCYANATES, HEAT.
Stability Condition to Avoid:TEMPERATURES ABOVE 95F MAY CAUSE DANGEROUS
PRESSURE IN SEALED CONTAINERS.
Hazardous Decomposition Products:CO2, CO, ORGANIC FRAGMENTS, NOX. HIGH
TEMPERATURE CAN DECOMPOSE FLUROCARBON TO ACIDS, TOXIC MATLS.
CHLORIDES, (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS SOLID INDUSTRIAL WASTE I/A/W
FEDERAL, STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DEOXIT DN5 - 5% SPRAY
Preparer's Name:MARK K. LOHKEMPER
CAGE:55403
CAGE:55403
============= Composition/Information on Ingredients =============
Ingred Name:1,1-DICHLORO-1-FLUOROETHANE; (GENETRON 141B). BP: 192.2F,
89C. VAP DENS: 4.1 (AIR=1).
CAS:1717-00-6
RTECS #:KI0997000
= Wt:75.
Ozone Depleting Chemical:2
Ingred Name:1,1,1,2-TETRAFLUOROETHANE; (DYMEL 134A) FL PT: NONE
CAS:811-97-2
= Wt:20.
Ingred Name:DEOXIT, NON-HAZARDOUS FL PT: 464F, 240C
= Wt:5.
Ingred Name:PETROLEUM NAPHTHA
CAS:8030-30-6
RTECS #:DE3030000
OSHA PEL:400 MG/M3;100 PPM
ACGIH TLV:1590 MG/M3;400 PPM
Ingred Name:ISOBUTANE/PROPONE
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN CONTACT: REPEATED OR PROLONGED
CONTACT MAY CAUSE ACUTE IRRITATION & DEFATTING OF SKIN. UNTREATED,
THIS CNDTNS COULD RESULT IN CHRONIC DERMATITIS. EYE CONTACT:
CONTACT W/LIQUIDS, MISTS OR VAPS OF THIS PROD CAN CAUSE ACUTE EYE
IRRIT, STINGING, AND SWELLING. INGESTION: HARMFUL IF SWALLOWED. MAY
CAUSE ACUTE IRRITATION OF THE LININGS OF MOUTH, NOSE & THROAT.
VOMITING MAY RESULT, CAUSING ASPIRATION OF MATL INTO THE LUNGS,
WITH THE PRODUCTION OF CHRONIC PULMONARY EDEMA CHEMICAL PNEUMONIA.
INHALATION: HARMFUL IF PRODUCT VAPORS ARE INHALED IN HIGH
CONCENTRATIONS. MAY CAUSE IRRITATION TO LINING OF LUNGS, (EFTS OF
OVEREXP)
Effects of Overexposure:HLTH HAZS: W/SUBSEQUENT CHRONIC PULM EDEMA.
ACUTE IRRIT OF MOUTH & NASAL PASSAGES MAY RSLT FROM OVEREXP.
DISPLACEMENT OF OXYGEN BY CHEMICAL VAPORS MAY LEAD TO DROWSINESS OR
UNCONSCIOUSNESS. NONE OF TH E COMPONENTS OF THIS PROD ARE KNOWN TO
HAVE CARCINOGENIC, MUTAGENIC, TERATOGENIC, SENSITIZATION EFTS.
BRTHG HIGH VAPOR CONCENTRATIONS FOR LONG PERIODS OF TIME MAY LEAD
TO NARCOSIS.
======================= First Aid Measures =======================
First Aid:SKIN CONTACT: WASH WITH SOAP AND WATER. SEEK MEDICAL
ATTENTION IF IRRITATION PERSISTS. ETE CONTACT: IMMEDIATELY FLUSH
WITH PLENTY OF WATER. REMOVE ANY CONTACT LENSES AND CONTINUE
FLUSHING FOR AT LEAST 15 MINUTES. SEEK MEDICAL ATTENTION IF
IRRITATION DEVELOPS OR PERSISTS. INGESTION: SEEK MEDICAL ATTENTION
IMMEDIATELY. INDUCE VOMITING ONLY AS DIRECTED BY MEDICAL PERSONNEL.
INHALATION: REMOVE TO FRES H AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT GIVE OXYGEN. SEEK MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:=240.C, 464.F
Extinguishing Media:SUITABLE - ALCOHOL FOAM, WATER FOG, DRY CHEMICAL,
CARBON DIOXIDE. NOT TO BE USED: WATER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:SPECIAL EXPOSURE HAZARDS: CARBON DIOXIDE,
CARBON MONOXIDE, HYDROCARBONS. HMIS LABELING: HEALTH: 1 (SLIGHT);
FLAMMABILITY: 0 (LEAST); REACTIVITY: 1 (SLIGHT).
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH APPRVD RESP PROT IN CONFINED SPACES
VENT AREA & REMOVE ALL SOURCES OF IGNITION. AVOID RUNOFF INTO
SEWERS & DITCHES THAT LEA D TO WATERWAYS. OBSERVE RECOMS FOR
PERSONAL PROT EQUIP DETAILED IN SECTION 8. FOR LARGE SPILLS, ABSORB
W/INERT MATL SUCH AS SAND, CLAY OR DIRT & PLACE IN SEALED METAL
CNTNR FOR DISP. (SUPDAT)
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE, AWAY FROM
HEAT, SPARKS OR FLAMES. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN
USE. DO NOT STORE IN DIRECT SUNLIGHT. KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:AVOID PRLNGD/RPTD CONTACT W/SKIN, EYES OR CLTHG.
AVOID BRTHG PROD VAPOR FOR EXTENDED PERIODS OF TIME. USE ONLY
W/ADEQ VENT. GENERAL VENT SHOULD BE ADEQ, BUT USE LOCAL EXHAUST
VENT IN CONFINED SPACES O R AT POINTS OF EXCESSIVE DISCHARGE. AVOID
ACTIVITIES THAT COULD CAUSE SPLASHING OF SPILLED MATERIAL OR
CREATE MISTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED FULL-FACE RESPIRATOR MASK
EQUIPPED WITH ACID GAS/ORGANIC VAPOR CARTRIDGE OR FUME HOOD OR
OTHER TYPE OF LOCAL EXHAUST VENTILATION.
Ventilation:GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL
AIRBORNE VAPOR LEVELS. LOCAL EXHAUST VENTILATION SHOULD BE USED IF
LARGE AMOUNTS ARE RELEASED.
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
OTHER: NONE REQUIRED FOR NORMAL CONDITIONS OF INDUSTRIAL USE.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING WHEN USING
THIS PRODUCT.
Supplemental Safety and Health
SPILL PROC: SINCE PRODS ARE NOT NORMALLY USED IN LARGE QTYS & PROD IS
NON-HAZ, ABSORB W/INERT MATL & DISCARD AS YOU WOULD MINERAL OIL.
CNDTNS TO AVOID: REQ USE OF STABILIZERS. WILL NOT DEGRADE TO UNST
ABLE PRODS. CHANGE IN COLOR SIGNIFIES EXPOS TO ULTRAVIOLET LIGHT OR
EXCEEDING SHELF LIFE; DISCARD SOLUTION.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE ING 1
Vapor Pres:10.02 PSIA @ 70F
Spec Gravity:N/E
Viscosity:APPROX 1 (H*2O=1)
Appearance and Odor:AEROSOL LIQUID, DEOXIT (LIGHT RED); ETHERAL/SWEET
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT SPRAY AROUND OPEN FLAMES, SPARKS OR
HOT METAL SURFACES. HAZ EXOTHERMIC POLYM WILL NOT OCCUR. NOT
SENSITIVE TO PRESS, LIGHT OR SHOCK. WILL NOT REACT W/WATER. DOES
NOT (SUPDAT)
Hazardous Decomposition Products:OXIDES OF CARBON & UNBURNED
HYDROCARBONS.
=================== Toxicological Information===================
Toxicological Information:TOX STUDIES OF 141B: ACUTE INHAL:ALBINO RATS
(SPRAQUE-DAWLEY) 4 HR-LC50 62,000PPM. SUBCHRONIC INHAL:INCR
CHOLESTEROL/DECR BODY WT 20,000PPM, NOEL 8,000PPM. ORAL:NOT-TOX, >5
G/KG BODYWT. CARD SENSIT TH RESHOLD: 10,000PPM TERATOLOGY,
RAT-MATERNAL & FETAL TOX 20,000PPM. NOEL 8,000PPM. REPRO
(2-GENERATION) RAT:REDUCED FERTILITY & REDUCED BODY WT 20,000PPM.
GENETIC STUDIES:AMES ASSAY NOT ACTIVE. CHO CEL L (GAS) POS, UP TO
10%. CHO CELL (LIQ) NOT ACTIVE, UP TO 13MG/L. HUMAN LYMPHOCYTE, NOT
ACTIVE, UP TO 35%. HGPRT-V79, NOT ACTIVE, UP TO 35%. IN VIVO MOUSE
MICRONUCLEUS, NOT ACTIVE, UP TO 36,000PPM. FOR ADDNL INFO CNTCT
ALLIED SIGNAL CHEMS.
===================== Ecological Information =====================
Ecological:MOBILITY: NO PRODUCT-SPECIFIC DATA IS AVAILABLE. PERSISTENCE
AND DEGRADABILITY: NO PRODUCT-SPECIFIC DATA AVAILABLE.
BIOACCUMULATIVE POTENTIAL: NO PRODUCT-SPECIFIC DATA AVAILABLE.
AQUATIC TOXICITY: NO PRODUCT-SPECIFIC DATA IS AVAILABLE. OTHER
DATA PERTAINING TO ECOTOXICITY: IN LARGE QUANTITIES, WATER RUNOFF
MAY CAUSE ENVIRONMENTAL DAMAGE.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT WASTE IS SUITABLE FOR FUELS BLENDING FOR
ENERGY RECOVERY OR DISPOSAL BY INCINERATION. PRODUCT MAY BE
RECOVERABLE BY DISTILLATION OR RECYCLING. LANFILLING IS NOT
RECOMMENDED FOR DISPOSAL. PACKA GE, TRANSPORT AND DISPOSE OF IN
ACCORDANCE WITH LOCAL OR NATIONAL REGULATIONS THAT APPLY TO
SUBSTANC ES AND PREPARATIONS OF THIS NATURE.
=================== MSDS Transport Information ===================
Transport Information:DOT - SHIPPING NAME: CONSUMER PRODUCT; CLASS:
ORM-D; UN NO: NOT REQUIRED. IMDG - SHIPPING NAME: AEROSOL PRODUCTS;
CLASS: 2; UN NO: 1950; IMDG CODE: PAGE 2102; LABEL: NOT REQUIRED.
IATA - UN NO: ID-800 ; CLASS OR DIVISION: 9; LABEL: NON-FLAMMABLE
GAS; SUBSIDIARY RISK: NONE; PACKAGE INSTRUCTIONS: 910; EMS:
CHEMTREC-USA; MFAG NO: #DN5S; MARINE POLLUTANT: NO. OTHER
INFORMATION: H.M. CUSTOMS HARMONIZED SYSTEM COMMODITY CODE:
===================== Regulatory Information =====================
Federal Regulatory Information:ALL INGREDIENTS ARE LISTED ON THE TSCA
INVENTORY. COMPLIES W/EC DIRECTIVE 91/155/EEC. EC HAZARD WARNING
LABEL - SYMBOL & CLASSIFICATION: NON-FLAM. RISK PHRASES: NON-FLAM,
HARMFUL IF SWALLOWED. SFTY PH RASES: KEEP AWAY FROM SOURCES OF
IGNIT - NO SMKNG. AVOID CNTCT W/EYES. IN CASE OF INSUFFICIENT VENT,
WEAR SUITABLE NIOSH APPRVD RESP EQUIP. KEEP OUT OF REACH OF
CHILDREN. CNTNS: PETROLEUM NAPHTHA SOLV ENT. TO BE DISPOSED OF AS
HAZ WASTE. USERS SHOULD ALSO REFER TO ANY LOCAL OR NATIONAL REGS
THAT APPL Y TO SUBSTANCE OR PREPARATIONS OF THIS NATURE.
State Regulatory Information:OTHER INFO: DEOXIT D100S (MSDS #PDP100S).
ADDNL INFO: C-SBA, CAIG PRODUCT LINE BROCHURE; CPG100, PRODUCT INFO
- PROGOLD; C-D100, PRODUCT INFO - DEOXIT; C-MCL100, PRODUCT INFO -
CAILUBE MCL, SB-G100, T ECH INFO ON PROGOLD; SB-DP100, TECH INFO ON
DEOXIT & PRESERVIT; SB-DIR, DIRECTIONS FOR USE; SB-AE, APPLICATION
EXAMPLES (USES IN INDUSTRY); SB-Q&A, QUESTIONS & ANSWERS; SB-SPEC,
SPECIFICATIONS, COMPAR ISONS & COMPATIBILITY.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AEROSHELL GREASE 22
CAGE:54527
CAGE:54527
============= Composition/Information on Ingredients =============
Ingred Name:POLYALPHAOLEFINS
Fraction by Wt: 86%
Ingred Name:ALKYLATED AROMATIC AMINES (ACCD TO MFR:ORAL LD50,RAT >10
G/KG)
Fraction by Wt: 3%
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 0.5%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM NITRITE (SARA III)
CAS:7632-00-0
RTECS #:RA1225000
Fraction by Wt: 0.5%
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:AMITROLE (SARA III)
CAS:61-82-5
RTECS #:XZ3850000
Fraction by Wt: <.05%
OSHA PEL:0.2 MG/M3
ACGIH TLV:0.2 MG/M3; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE PRODUCT BY WIPING OR APPLYING WATERLESS HAND
CLEANER,FOLLOW BY WASHING W/SOAP & WATER.EYES:FLUSH W/WATER FOR AT
LEAST 15 MIN.INGEST:CONSULT MEDICAL PERSONNEL.
===================== Fire Fighting Measures =====================
Flash Point:455F COC
Extinguishing Media:DRY CHEMICAL TYPE PREFERRED
Fire Fighting Procedures:NONE SPECIAL
Unusual Fire/Explosion Hazard:NONE UNUSUAL
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP EXCESS GREASE.CLEAN AREA
W/APPROPRIATE CLEANER.
======================Handling and Storage ======================
Handling and Storage Precautions:WASH BEFORE EATING OR SMOKING.MINIMIZE
SKIN CONTACT.OBSERVE GOOD PERSONAL HYGIENE.LAUNDER CONTAMINATED
CLOTHING BEFORE USING.
Other Precautions:MFR STATES:THE CONC OF 3-AMINO-1,2,4-TRIAZOLE,SODIUM
NITRITE & SECONDARY AMINES THAT COULD FORM NITROSAMINES IS
LOW.HOWEVER,HANDLING & SAFETY PROCEDURES SHOULD BE STRICTLY
FOLLOWED,MIN EXPOS
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPRVD RES PROT AS REQUIRED TO
MIN EXPOS TO HOT VAP
Other Protective Equipment:OTHER CLOTHING AS NEEDED TO MINIMIZE SKIN
CONTACT
Supplemental Safety and Health
ADD INGRED:INORGANIC CLAY THICKENER,6%; FATTY AMIDES,3%:DICARBOXYLIC
ACID,1%;MINERAL ACID,0.5% 3-AMINO-1,2,4-TRIAZOLE ORAL
LD50,RAT=14.7G/KG.UNIT OF ISSUE:35LB CONTAINER
================== Physical/Chemical Properties ==================
HCC:V6
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SMOOTH AMBER GREASE.SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NO*X,CO & OTHER UNIDENT OXYGENATES CAN
FORM DURING COMBUST
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECM BURY OR INCINERATE IF IAW FED,STATE &
LOCAL CODES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:469-475 QUICK SET
Preparer's Name:DICK KARBO
CAGE:KMADD
CAGE:KMADD
============= Composition/Information on Ingredients =============
Ingred Name:BARIUM COMPOUNDS
Fraction by Wt: 11%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT W/SKIN/EYES CAN
CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/WATER. SKIN: WASH AFFECTED AREA
W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WIPE UP & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS. LARGE: SCOOP MATERIAL INTO SEALABLE
CONTAINERS. WIPE UP REMAINDER & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:WASH AFTER USE. REMOVE/LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. DON'T CONSUME FOOD/BEVERAGE WHERE PRODUCT IS
USED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:470-610F
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:INSOLUBLE
Appearance and Odor:OILY
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:USA 347
CAGE:JO533
CAGE:0AZS7
CAGE:JO533
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NICKEL (SARA 313) (CERCLA) (MFR'S CAS #7440-02-2)
CAS:7440-02-0
RTECS #:QR5950000
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
Ingred Name:MANGANESE (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:5 MG/M3 DUST, C
ACGIH TLV:5 MG/M3 DUST
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:NIOBIUM; (COLUMBIUM)
CAS:7440-03-1
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM FLUORIDE
CAS:7789-75-5
RTECS #:EW1760000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CLAY (KAOLIN); (ALUMINUM SILICATES)
CAS:1332-58-7
RTECS #:GF1670500
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:POTASSIUM SILICATES
CAS:1312-76-1
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CRYOLITE
CAS:15096-52-3
RTECS #:WA9625000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZIRCONIUM SILICATES
CAS:7440-42-6
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (QUARTZ)
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SUPDAT: BE REACHED BEFORE LIM OF 5 MG/M3 FOR GEN WELDING
FUMES IS REACHED. WATCH CR(VI) LEVEL. GASEOUS RXN PRODS(ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:MAY INCL CO & CO*2. OZONE & NITROGEN OXIDES MAY BE
FORMED BY RADIA FROM ARC. CONTACT NEHC FOR MORE INFO .
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN:CRYSTALLINE-QUARTZ:IARC MONO, V 68,
1997:GRP 1. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC TO BE CARCIN.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: IN LUNG) & IS BELIEVED TO AFFECT PULM
FUNC. REPETITIVE EXPOS TO FLUORIDE FUMES &/OR GASES MAY (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: CAUSE EXCESS CALCIFICATION OF BONES & LIGAMENTS OF
RIBS, PELVIS & SPINAL COLUMN. CHROMIUM(VI) CMPDS MAY (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:CAUSE ULCERATION & PERFORATION OF NASAL SEPTUM &
LIVER & KIDNEY DMG. REPETITIVE OVEREXP TO NICKEL OXIDES (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: MAY LEAD TO LUNG FIBROSIS OR PNEUMOCONIOSIS. ARC
RAYS CAN INJURE EYES & BURN SKIN. ELEC SHOCK CAN KILL.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LNGTH FSHLD W/FILTER LENS SHADE
#12-14/DARKER. SHIELD OTHERS BY PROVIDING SCREENS & FLASH GOGGS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE OVEREXP TO WELDING FUMES MAY
RSLT IN DISCOMFORT SUCH AS DIZZ, NAUS OR DRYNESS/IRRIT OF NOSE,
THROAT/EYES. INHAL OF EXTREMELY HIGH LEVELS OF FLUORIDES MAY CAUSE
ABDOM PAIN, DIARR, MUSC WEAK & CON VLS. CONTINUED INHAL COULD CAUSE
UNCON & DEATH. CHROMIUM (VI) CMPDS PRESENT IN FUME MAY CAUSE SEV
IRRIT(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL: IARC MONO, VOL 49, PG 257,
1990:GRP 2B. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC TO BE
CARCIN. SILICA, (ING 20)
Effects of Overexposure:HLTH HAZ: OF BRONCH TUBES & LUNGS. INGEST OF
CHROMIUM (VI) SALTS MAY CAUSE INJURY/DEATH. CHROMIUM(VI) CMPDS MAY
BURN EYES. CHROMIUM CMPDS MAY CAUSE ALLERGIC RXNS. NICKEL OXIDES IN
FUME MAY CAUSE TIGHT NESS AROUND CHEST, FEVER & ALLERGIC RXNS.
CHRONIC OVEREXP TO WELDING FUMES CAN LEAD TO SIDEROSIS (IRON
DEPOSITS (ING 21)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMED . EYES: IMMED FLUSH W/POTABLE WATER FOR
A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD . SKIN: FLUSH
W/COPIOUS AMTS OF WATER. CALL MD . CALL FOR MED ASSISTANC E. USE
FIRST AID PROCEDURERS RECOM BY AMERICAN RED CROSS. IF BREATHING IS
DFCLT, GIVE OXYGEN. IF NOT BREATHING USE CPR. CONSULT MD IF
IRRITATION OF EYES & SKIN OR FLASH BURNS DEVELOP AFTER EXPOSURE.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NON-FLAMMABLE: WELDING ARC AND SPARKS CAN
IGNITE COMBUSTIBLES. SEE Z-49.1 SAFETY IN WELDING & CUTTING,
PUBLISHED BY AWS, 550 NW LEJEUNE RD, MIAMI, FL 33126.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS &
PREC LABEL ON PROD. ADVISE WELDERS TO KEEP THEIR HEAD OUT OF FUMES.
SEE ANSI Z49.1 & 29 CFR 1910 FOR MORE INFO.
Other Precautions:ONE METHOD OF DETERMINING COMPOSITION & QTY OF FUMES
& GASES TO WHICH WORKERS ARE EXPOSED IS TO TAKE AIR SAMPLE FROM
INSIDE WELDER'S HELMET WHILE WORN OR IN WORKER'S BREATHING ZONE.
SEE ANSI/AWS F1.1 AVAIL FROM AMERICAN WELDING SOCIETY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRABLE FUME RESPIRATOR OR
AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACE OR GENERAL
WORK AREA WHERE LOCAL EXHAUST AND/OR VENTILATION DOES NOT KEEP
EXPOSURE BELOW THE THR ESHOLD LIMIT VALUE.
Ventilation:USE PLENTY OF VENT &/OR LOC EXHST AT ARC TO KEEP FUMES &
GASES BELOW TLV W/IN WORKER'S BRTHG ZONE & GEN WORK AREA.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . ARM
PROTECTORS, APRON, HATS, SHOULDER PROT & DARK SUBSTANTIAL CLTHG.
Work Hygienic Practices:TRAIN WELDER NOT TO ALLOW ELEC LIVE PARTS TO
GROUND.
Supplemental Safety and Health
HAZ DECOMP PRODS: WELDED, PROCS FOLLOWED & ELECTRODES USED. REASONABLE
EXPECTED FUME CONSTITUENTS OF PROD WOULD INCL: COMPLEX OXIDES OF
ALUMINUM, IRON, MANGANESE, SILICON, TITANIUM, CHROMIUM, NICKEL,
CALCIUM, COLUMBIAN, MOLYBDENUM & COPPER. FLUORIDES WILL ASLO BE
PRESENT. FUME LIM FOR (CR(VI)(0.05 MG/M3) MAY (ING 18)
================== Physical/Chemical Properties ==================
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES & GASES CANNOT BE
CLASSIFIED SIMPLY. COMPOSITION & QTY OF FUMES & GASES DEPEND ON
METAL BEING (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER
OR LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER APPROVED BY
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:65550 METHANOL
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS
CAS:67-56-1
RTECS #:PC1400000
Other REC Limits:200 PPM
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 5628 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE FATAL IF SWALLOWED. HARMFUL IF
INHALED OR ABSORBED THROUGH SKIN. VAPOR OR MIST IS IRRITATING TO
THEY EYES, MUCOUS MEMBRANES, SKIN, & UPPER RESPIRATORY TRACT. CAN
CAUSE DAMAGE TO THE EYES, LIVER , HEART, KIDNEYS. GASTROINTESTINAL
DISTURBANCES & CONVULSIONS. MAY CAUSE BLINDNESS IF INGESTED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:OPTIC NERVE NEUROPATHY, VISUAL FIELD CHANGES,
HEADACHE, DYSPNEA, NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:CUTS, SCRATCHES
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS WHILE
REMOVING CONTAMINATED CLOTHING & SHOES. INHALATION: REMOVE TO FRESH
AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHIG IS
DIF FICULT, GIVE OXYGEN. INGESTION: WASH OUT MOUTH W/WATER PROVIDED
PERSON IS CONSCIOUS. DISCARD CONTAMINATED CLOTHING & SHOES. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:52F
Lower Limits:6%
Upper Limits:36%
Extinguishing Media:CO2, DRY CHEMICAL POWDER OR APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAPOR MAY TRAVEL CONSIDERABLE DISTANCE TO
SOURCE OF IGNITION & FLASH BACK. EXTREMELY FLAMMABLE. AUTOIGNITION
TEMP: 725F.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. SHUT OFF ALL IGNITION SOURCES.
USE PROTECTIVE EQUIP. COVER W/DRY-LIME, SAND OR SODA ASH. PLACE IN
COVERED CONTAIERS USING NON-SPARKING TOOLS & TRANSPORT OUTDOORS.
VENTILATE AREA & WASH SPILL SITE AFTER MATERIAL PICKUP IS
COMPLETE.
Neutralizing Agent:DRY LIME, SAND OR SODA ASH
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED & AWAY FROM HEAT,
SPARKS & OPEN FLAME. PRODUCT IS HYGROSCOPIC. STORE IN A COOL DRY
PLACE. NO SMOKING. CANNOT BE MADE NON-POISONOUS
Other Precautions:AVOID CONTACT W/EYES, SKIN, CLOTHING & BREATHING OF
VAPORS. DON'T USE IF SKIN IS CUT OR SCRATCHED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR AN APPROPRIATE NIOSH/MSHA APPROVED
RESPIRATOR.
Ventilation:MECHANICAL EXHAUST
Other Protective Equipment:RUBBER BOOTS, SAFETY SHOWER, EYE BATH
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:64.6C
Melt/Freeze Pt:M.P/F.P Text:-98C
Vapor Pres:97.68
Vapor Density:1.1
Spec Gravity:0.791
Appearance and Odor:COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, ACID CHLORIDES, ACID ANHYDRIDES, OXIDIZING/REDUCING AGENTS,
ALKALI METALS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME OR OTHER SOURCES
OF IGNITION.
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN
AFTERBURNER & SCRUBBER BUT EXERT EXTRA CARE IN IGNITING AS THIS
MATERIAL IS HIGHLY FLAMMABLE. OBSERVE ALL FEDERAL, STATE & LOCAL
LAWS. UN1230.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ASBESTOS FILLED SPIRAL WOUND GASKET
CAGE:58156
CAGE:2K255
CAGE:58156
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:NATURAL LATEX
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING, FILING,
ETC.) MAY CONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE TO AIRBORNE
FIBERS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA. SMOKING COMBINED
WITH FIBER INHALATION GREATLY INCREASES LUNG CANCER RISK.
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:EYES: POTENTIAL IRRITATION FROM AIRBORNE DUST.
SKIN: UNKNOWN. INHALATION: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS AND MESOTHELIO MA. INGESTION: UNKNOWN.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. IF IRRITATION
PERSISTS GET MEDICAL ATTENTION. SKIN: WASH AREA WITH SOAP AND
WATER. INHALATION: MOVE TO FRESH AIR. GET MEDICAL ATTENTION.
INGESTION: GET MEDICAL ATTENTION. OTHER: CHANGE CLOTHING AS
REQUIRED TO AVOID CARRYING DUST PARTICLES INTO OTHER AREAS.
===================== Fire Fighting Measures =====================
Extinguishing Media:MATERIAL IS NOT FLAMMABLE. USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED
WITH AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS
FIBERS TO THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MANNER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION WHEN WORKING WITH THIS MATERIAL.
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS AND
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED AND BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A NIOSH/
MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED. CONSULT YOUR
SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DON'T INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS.AVOID AIRBORNE DUST
CREATION.
Supplemental Safety and Health
AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT A HAZARD. HEALTH
DATA IS BASED ON AIRBORNE DUST CREATED FROM ABRASIVE ACTIONS (EG.
CUTTING, MACHINING, FILING, ETC.) THAT CONTAIN ASBESTOS FIBERS.
================== Physical/Chemical Properties ==================
HCC:T6
Spec Gravity:2.5
Evaporation Rate & Reference:NONE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:MANUFACTURED COMMODITY. LIGHT BLUE. NO ODOR.
Percent Volatiles by Volume:NONE
Corrosion Rate:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FR IABLE OR NON-FRIABLE".
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:V114 X 3523
Preparer's Name:D MARTINSON
CAGE:25670
CAGE:25670
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 77%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE/THROAT/MUCOUS
MEMBRANES IRRITATION. SKIN: SEVERE IRRITATION/BURNS/DERMATITIS.
EYES: SEVERE IRRITATION/BURNS. INGESTION: LOW ORDER TOXICITY. SMALL
AMOUNTS ASPIRATED INTO LUNGS FROM ING ESTION/VOMITING MAY CAUSE
BRONCHIOPNEUMONIA/PULMONARY EDEMA. ASPIRATED METHYL ETHYL KETONE
MAY CAUSE SEVER LUNG DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHES, DIZZINESS, DROWSINESS,
UNCOORDINATION, NAUSEA, UNCONSCIOUSNESS, DRY SKIN, VOMITING,
DIARRHEA, BURNING.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR/KEEP WARM/RESTORE BREATHING IF
REQUIRED. EYES:WASH W/LARGE AMOUNTS OF WATER.
INGESTION:ASPIRATION-HAZARD DON'T INDUCE VOMITING.IF VOMITING
OCCURS SPONTANEOUSLY/KEEP HEAD BELOW HIPS TO PREVENT BREATHING
VOMITUSINTO LUNGS.OBTAIN MEDICAL ATTENTION IN ALL CASES.NOTE TO
PHYSICIAN:QUICKLY EVACUATE STOMACH CONTENTS IN ALL MANNER WHICH
AVOIDS ASPIRATION.NO SPECIFIC ANTIDOTE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:20F
Lower Limits:1.4
Upper Limits:11.4
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS
Unusual Fire/Explosion Hazard:VOLATILE SOLVENT CONSTITUENT CAN READILY
FORM EXPLOSIVE/FLAMMABLE MIXTURES IN AIR. VAPORS CAN FLOW ALONG
SURFACES TO DISTANT IGNITION SOURCES & FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:HANDLE AS A FLAMMABLE LIQUID. REMOVE ALL
IGNITION SOURCES. SOAK UP WET MATERIAL ON A NON-COMBUSTIBLE
ABSORBENT & PLACE IN A CLOSED METAL CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL/WELL VENTILATED AREA
AWAY FROM IGNITION SOURCES/STRONG OXIDIZING AGENTS. KEEP CONTAINERS
TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:DON'T TRANSFER TO PLASTIC CONTAINERS. GROUND/BOND
METAL CONTAINERS WHEN DISPENSING. NO SMOKING IN AREA OF
USE/STORAGE. USE ONLY NON-SPARKING TOOLS NEAR WET ADHESIVE/SOLVENT
VAPORS. (SEE SUPP)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MATERIAL NOT SUITED FOR SPRAY, IN
RESTRICTED/NON-VENTILATED AREAS WHERE VAPOR EXPOSURE MAYBE
ENCOUNTERED, USE RESPIRATOR W/ORGANIC SOLVENT ABSORBING
FILTER/INDEPENDENT AIR SUPPLY.
Ventilation:MECHANICAL VENTILATION/LOCAL EXHAUST
Other Protective Equipment:SAFETY GLASSES W/SIDE SHIELDS, EYE WASH
FOUNTAIN/BOTTLES, SOLVENT INSOLUBLE BARRIER HAND CREAM.
Work Hygienic Practices:DON'T USE CONTACT LENSES. WASH CONTAMINATED
CLOTHING BEFORE REUSE.
Supplemental Safety and Health
OTHER PRECAUTIONS CONT'D: SOLVENT VAPORS MUCH HEAVIER THAN AIR & CAN
COLLECT IN DANGEROUS CONCENTRATIONS IN FLOOR DRAINS/LOW AREAS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:176F
Vapor Density:>1
Spec Gravity:0.9
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:LOW VISCOSITY BLUE LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:SOURCES OF IGNITION, HEAT
Hazardous Decomposition Products:NITROUS OXIDE, PHENOLS, CO2, CO,
HYDROGEN CYNIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TEMCO TC-2;CLEANER & DEGREASER
CAGE:67095
CAGE:67095
============= Composition/Information on Ingredients =============
Ingred Name:DETERGENTS (ALKALINE)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Health Hazards Acute and Chronic:ACUTE:CORROSIVE TO EYES AND IRRITATES
SKIN TISSUES. CHRONIC:NOT KNOWN.
Medical Cond Aggravated by Exposure:NOT KNOWN
======================= First Aid Measures =======================
First Aid:SKIN:WASH WITH SOAP AND WATER. EYES: FLUSH WITH WATER.
INHALED: REMOVE TO FRESH AIR. REMOVE CONTAMINATED CLOTHING. ING:
DRINK CITRUS JUICE, MILK, VINEGAR OR WATER. SEE DOCTOR IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA IN AN ENCLOSED
AREA.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH INERT MTERIAL AND PLACE IN
SUITABLE DISPOSAL CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL AREA AWAY FROM ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQMNTS UNDER ORDINARY
CONDITIONS/ADEQUATE VENT.
Ventilation:MECH(GEN)OR LOCAL EXHAUST THAT PROVIDES ADEQUATE
VENTILATION
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST/WASH THOROUGHLY AFTER EACH USE.
Supplemental Safety and Health
MSDS UNDATED AND RECEIVED BY DGSC:OCT 9, 1987.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.16
Solubility in Water:COMPLETE
Appearance and Odor:BRIGHT, PINK LIQUID, SASSAFRASS ODOR.
Percent Volatiles by Volume:50
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS
Stability Condition to Avoid:NONE NOTED
Hazardous Decomposition Products:NONE NOTED
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A/D HIGH HEAT ARGENT SILVER, 0702A33M
Preparer's Name:J. TILLOTSON
CAGE:57294
CAGE:98795
CAGE:57294
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL BENZENE. VP: 7.1@20C
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: <10%
OSHA PEL:100 PPM;125 STEL
ACGIH TLV:100 PPM;125 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LIGROINE; (PETROLEUM SOLVENT). VP: 9.5@20C
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 10-20%
OSHA PEL:300 PPM;400 PPM STEL
ACGIH TLV:300 PPM
Ingred Name:XYLENE. VP: 21@20C
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10-20%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOBUTYL ALCOHOL; (ISOBUTANOL). VP: 8@20C
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: <10%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ALUMINUM
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 32-33%
OSHA PEL:15 MG/M3(TDUST)
ACGIH TLV:10 MG/M3(DUST)
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 3.4 POUNDS PER GALLON LESS
WATER.
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: OVEREXPOSURE BY INHAL MAY CAUSE
IRRIT OF RESP TRACT, HDCH, DIZZ/DROW. SKIN/EYE CONT: IRRITANT TO
EYES & SKIN. CHRONIC: THOSE HAZ MATERIALS MAY AFFECT THE FOLLOWING
ORGANS: RESPIRATORY TRACT, CE NTRAL NERVOUS SYSTEM, KIDNEYS, LIVER,
CARDIAC SENSITIZATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:UNKNOWN AT THIS TIME.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. EYE: FLUSH IMMEDIATELY WITH
LARGE AMOUNTS OF RUNNING WATER FOR AT LEAST 15 MINUTES. SKIN:
REMOVE CONTAMINATED CLOTHING AND WASH SKIN WITH SOAP AND WATER.
INGEST: DRINK WAT ER.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:74.0F,23.3C
Lower Limits:0.90%
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL, OR CARBON
DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, AVOID
BREATHING VAPORS, VENTILATE AREA, & REMOVE W/INERT ABSORBANT &
NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT TAKE INTERNALLY. CONTRS SHOULD
BE GROUNDED WHEN POURING. AVOID FREE FALL OF LIQ IN EXCESS OF A FEW
INCHES.
Other Precautions:MAKE SURE DRUM IS COMPLETELY CLEANED PRIOR TO USE. DO
NOT FLAME CUT, BRAZE, OR WELD W/OUT NIOSH/MSHA APPROVED RESPIRATOR
OR APPROPRIATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE GEN DILUTION/LOC EXHAUST FAILS TO ADEQ
DILUTE TWA/PEL OF MATL, THEN NIOSH/MSHA APPRVD RESP PROT SHOULD BE
USED AS FOLLOWS: I/A/W 29CFR1910.134, USE NIOSH/MSHA APPRVD AIR
LINETYPE RESP/HOODS FOR ENCLSD & CONFINED AREAS. (SUPP DATA)
Ventilation:PROVIDE GEN DILUT/LOC EXHAUST VENT TO KEEP TWA AND LEL
BELOW ACCEPTABLE LIMITS AND TO REMOVE DECOMP PROD.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
RESP PROT: NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATORS MAY BE USED
FOR OTHER AREAS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>226F,>108C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:9.892
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FUMES MAY CNTN CARBON MONOXIDE &
OXIDES OF NITROGEN. MAY PRDCE HAZ FUMES WHEN HEATED TO
DECOMPOSITION AS IN WELDING.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:F42-0412 CLC 700/800 STARTER BLUE(CYAN)
Preparer's Name:JOSEPH PALMERI
CAGE:EO160
CAGE:EO160
CAGE:EO274
CAGE:08YZ7
CAGE:4J871
============= Composition/Information on Ingredients =============
Ingred Name:FERRITE POWDER MIXTURE, INCLUDES INGREDS 2-4
Fraction by Wt: 90-95%
Other REC Limits:NONE RECOMMENDED
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: SEE #1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5MG(FE)/M3FUME,B2;96
Ingred Name:ZINC OXIDE (SARA 313) (CERCLA)
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: SEE #1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:CUPRIC OXIDE
CAS:1317-38-0
RTECS #:GL7900000
Fraction by Wt: SEE #1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG CU/M3
ACGIH TLV:1 MG CU/M3
Ingred Name:POLYESTER RESIN
CAS:39382-25-7
Fraction by Wt: 3-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PIGMENT (BLUE)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL,RATS>5000MG/KG,SIMILAR TONER
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:EXPECTED TO BE LOW HAZ FOR
RECOMMENDED HNDLG.EYE:NO SPECIFIC HAZ KNOWN.MAY CAUSE TRANSIENT
IRRIT.NOT CLASSIFIED AS IRRIT ACCORDING TO OSHA HCS.SKIN:EXPECTED
TO BE LOW HAZ FOR RECOMMENDED HNDLG.N OT CLASSIFIED AS IRRIT
ACCORDING TO OSHA HCS.INGETS:EXPECTED TO BE LWO INGEST HAZ.CHRONIC
TOXICITY:NO DATA AVAILABLE.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY
CLASSIFICATION:IARC/NTP/OSHA:NONE.
Effects of Overexposure:BASED UPON AVAI DATA HUMAN EXPO TO TONER HAS
BEEN SHOWN TO CAUSE MIN RESP TRACT IRRIT AS MAY OCCUR W/LG AMTS OF
ANY NON-TOXIC DUSTS.RESULTS OF 1 ANIMAL STUDY WHERE RATS INHAL
TONER THAT WAS 10X MORE R ESPIRABLE THAN COMMERC AVAI TONER WERE
OBSERVED TO HAVE NO LUNG CHANGES @LOW EXPO(MOST RELEVANT LEVEL TO
HUMANS)(SUPPLE)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:IF SYMPTOMATIC MOVE TO FRESH AIR.GET MEDA TTN IF
SYMPTOMS PERSIST.EYE:ANY MATL THAT CONTACT EYE SHOULD BE WASHED OUT
IMMED W/WATER.GET MED ATTN IF SYMPTOMS OCUR.SKIN:WASH
W/SOAP/WATER.GET MED AT TN IF SYMPTOMS OCCUR.INGEST:DRINK 1-2
GLASSES OF WATER.SEEK MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE (CO2),DRY CHEMICAL.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:POWDERED MATL MAY FORM EXPLISVE DUST-AIR
MIXTURES. NON-FLAMMABLE SOLID (ACCORDING TO TEST METHODS OF
16CFR1500.44).
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP MATERIAL ONTO PAPER AND PLACE IN FIBER
CARTON.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING DUST.USE W/ADEQUATE
VENTI.KEEP FROM CONTACGT W/OXIDIZING MATLS.MINIMIZE DUST
GENERATION/ACCUMULATION.KEEP CNTNR CLOSED.
Other Precautions:REF PAMPHLET #654:"PREVENTION OF FIRE/DUST EXPLO IN
CHEMS,DYE,PHARMACEUT,PLASTICS INDUSTRIES".MATL HASNT BEEN TESTED
FOR ENVIRO EFFEECTS.IN SPILL SITUTAION MATL MAY BE VISUALLY
UNPLEASANT;HOWEVER NOT EXPECTED TO CAUSE ADVERSE ENVIRO EFFECTS
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD VENTI(TYPICALLY 4-6 ROOM VOL/HR)SHOLD BE
USED.VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS.
Other Protective Equipment:WASHING FACILITIES.
Work Hygienic Practices:WASH WELL AFT HNDLG.GOOD INDUST HYGIENE PRAC
SHOULD BE FOLLOWED WHICH INCLUDES PREVENT EYE CONTACT,MIN SKIN
CONTACT/INH.
Supplemental Safety and Health
OVEREXPO:@HIGHER LEVELS SLIGHT DEGREEE OF LUNG FIBROSIS WAS OBSERVED
DUE TO EXCESSIVE AMTS OF DUST RETAINED IN LUNGS FOR PROL INTERVAL.
RCRA:DISCARDED IN PURCHASED FORM PROD WOULDNT BE HAZ WASTE.HOWEV ER
END USER RESPONSIBILITY TO DETERMINE@DISPO TIME WHETHER MATL
CONTAINING PROD/DERIVED FRM PROD SHOULD BE HAZ WASTE.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NP
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NP
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:4.0-4.5
pH:NA
Evaporation Rate & Reference:NA
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SOLID POWDER, BLUE (CYAN) COLOR, SLIGHT PLASTIC
ODOR
Percent Volatiles by Volume:NA
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON
MONOXIDE.COMBUSTION WILL PRODUCE CO2,POSSIBLY TOXIC CHEMS SUCH AS
CO OR OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE/LANDFILL.CAN BE INCINERATED WHEN IN
COMPLIANCE W/LOC REGS.DISCH/TREAT/DISPO MAY BE SUBJ TO
NAT/STATE/LOC LAWS.EMPTY RECEPTACLE MAY BE RECYLCLE.CHEM SUBJ TO
SEC 313 TITLE III SARA/40CFR372:C OPPER/CMPDS 15%,AS CU
12%,ZINC/CMPDS 15%,AS ZN 12%
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METHYL SALICYATE
CAGE:99559
CAGE:99559
============= Composition/Information on Ingredients =============
Ingred Name:METHYL SALICYLATE
CAS:119-36-8
RTECS #:VO4725000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50(ORAL, RAT) = 887 MG / KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE- INHALATION:MAY IRRITATE THE
NOSE AND THROAT. EYES:IRRITATION.SKIN:IRRITATION AND
SENSITIZATION. INGESTION:HARMFULL IF SWALLOWED. CHRONIC:PROLONGED
CONTACT WITH THE SKIN MAY CAUSE SENSITIZA TION.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR IMMEDIATELY. GIVE OXYGEN OR
ARTIFICIAL RESPIRATION AS NEEDED. EYES:IRRIGATE WITH PLENTY OF
WATER FOR AT LEAST 15 MIN.OBTAIN EMERGENCY MEDICAL ATTENTION.
SKIN:REMOVE CONTAMINATED CLOTHING AS NEEDED. WASHSKIN THOROUGHLY
WITH MILD SOAP AND WATER. OBTAIN MEDICAL ATTENTION IF IRRITATION
DEVELOPS. INGESTION:INDUCE VOMITING. OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:205F,96C
Extinguishing Media:USE CARBON DIOXIDE, FOAAM, OR DRY CHEMICL TO
EXTINGUISH FIRE. WATER CAN BE USED TO COOL, BUT NOT FOR
EXTINGUISHING.
Fire Fighting Procedures:WEAR SELF-COONTAINED, POSITIVE PRESSURE
BREATHING APPARATUS AND FULL FIREFIGHTING PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:DECOMPOSITION UNDER FIRE CONDITIONS WILL
GENERATE CARBON MONOXIDE AND PHENOL AND MAY GENERATE OTHER TOXIC
VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION, STOP RELEASE, AND
PROVIDE ADEQUATE VENTILATION. PREVENT FLOW TO SEWERS AND PUBLIC
WATERS. RECOVER FREE PRODUCT, IF POSSIBLE. COVER SPILL WITH
INERT, NON-COMBUSTIBLE ABSOR BANT MATERIAL AND REMOVE TO DISPOSAL
CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AS A NFPA CLASS IIIA LIQUID.
KEEP FIRE AND SPARKS AWAY FROM DRUMS.
Other Precautions:EMPTY CONTAINERS RETAIN PRODUCT RESIDUE. DO NOT CUT,
GRIND, DRILL, OR WELD ON OR NEAR THE CONTAINER UNTIL IT HAS BEEN
COMPLETELY CLEANED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATORY PROTECTION IN
CONFINED OR ENCLOSED SPACES.
Ventilation:USE WITH ADEQUATE LOCAL EXHAUST VINTILATION.
Other Protective Equipment:PROVIDE SAFETY SHOWER, EQUIPPED WITH AN EYE
WASH FOUNTAIN IN THE IMMEDIATE VICINITY OF ANY POTENTIAL EXPOSURE.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE PRACTICES. WASH
HANDS BEFORE EATING, DRINKING, OR SMOKING, OR USING TOILET
FACILITIES.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:433F,223C
Melt/Freeze Pt:M.P/F.P Text:16.0F,-8.9C
Vapor Pres:< 1 MM HG
Vapor Density:5.26
Spec Gravity:1.183
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE (0.07%)
Appearance and Odor:COLORLESS LIQUID WITH ODOR OF WINTERGREEN
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS AND STRONG ALKALIES. TRACES OF IRON WILL CAUSE
DISCOLORATION.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE AND PHENOL. MAY
GENERATE TOXIC VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE MADE IN ACCORDANCE WITH
APPLICABLE GOVERNMENTAL REGULATIONS. DO NOT CONTAMINATE ANY
STREAM, LAKES, OR PONDS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-126-1433
Product ID: EPOLITE 3300-3301 RESIN
Kit Part: Y
Cage: MO998
Box: 2197
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 52331
Cage: MO998
Box: 2197
Cage: 01490
Box: 2197
=======================================================
Item Description Information
=======================================================
Specification Number: NONE
Type/Grade/Class: NONE
Type of Container: UNKNOWN
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: UNKNOWN
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE- SKIN CONTACT MAY CAUSE IRRITATION.
REPEATED/PROLONGED EXPOSURE CAN CAUSE DERMATITIS & SKIN SENSITIZATION.
INGESTION MAY CAUSE GI TRACT BURNING. VAPORS ARE EXCEEDINGLY IRRITATING TO
MUCOUS MEMBR ANES & EYES. CHRONIC- DERMATITIS. TARGETORGANS:EYES, SKIN,
RESPIRATORY & GASTROINTESTINAL TRACTS.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: EYES, SKIN, RESPIRATORY AND
GASTROINTESTINAL TRACTS IRRITATION, BURNS
Medical Cond Aggravated By Exposure: PRE-EXISTING EYE, SKIN & RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
First Aid: GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN:WASH WITH SOAP &
WATER. REMOVE CONTAMINATED CLOTHING. EYE:FLUSH WITH WATER FOR 15 MINUTES,
HOLDING EYELIDS OPEN. INHALED:REMOVE TO FRESH AIR & PROVIDE O XYGEN/CPR
IF NEEDED. ORAL:GET MEDICAL ATTENTION IMMEDIATELY. IF CONSCIOUS, INDUCE
VOMITING ONLY UPON THE ADVICE OF A PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: VENTILATE AREA. CONTAIN SPILL AND ABSORB WITH SAND,
SAWDUST OR OTHER SUITABLE ABSORBANT. PLACE INTO OPEN-TOPPED CONTAINERS AND
COVER LOOSELY FOR 12 HOURS. SEAL THE CONTAINERS.
Neutralizing Agent: UNKNOWN
Waste Disposal Methods: CONTROLLED INCINERATION OR BURIED LANDFILL DISPOSAL
SHOULD BE IN ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS.
Handling And Storage Precautions: STORE IN COOL, WELL VENTILATED AREA IN
TIGHTLY CLOSED CONTAINERS. AVOID MOISTURE CONTAMINATION.
Other Precautions: AVOID BREATHING VAPORS. DO NOT GET IN EYES, ON SKIN OR ON
CLOTHING. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR DRINKING.
REMOVE CONTAMINATED CLOTHING PROMPTLY. KEEP OUT OF REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 400F,204C
Extinguishing Media: USE DRY CHEMICAL OR CARBON DIOXIDE FOR SMALL FIRES AND
WATER AND FOAM FOR LARGE FIRES.
Fire Fighting Procedures: WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. COOL FIRE-EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard: UNKNOWN
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NORMALLY REQUIRED.
Ventilation: IF HANDLED INDOORS, PROVIDE MECHANICAL EXHAUST VENTILATION.
Other Protective Equipment: EYE WASH STATION, EMERGENCY SHOWER
Work Hygienic Practices: OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health: KEY1:N1. "EMPTY" CONTAINERS RETAIN RESIDUE AND
CAN BE DANGEROUS. DO NOT CUT, WELD, SOLDER, DRILL OR EXPOSE SUCH CONTAINERS
TO HEAT, FLAME, SPARKS.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: B2
NRC/State LIC No: NOT RELEVANT
B.P. Text: UNKNOWN
M.P/F.P Text: UNKNOWN
Decomp Text: UNKNOWN
Vapor Pres: UNKNOWN
Vapor Density: UNKNOWN
Spec Gravity: 2.40
Evaporation Rate & Reference: UNKNOWN
Solubility in Water: UNKNOWN
Appearance and Odor: THICK BLACK LIQUID; MILD SWEET ODOR.
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXCESSIVE HEAT, MOISTURE, CROSS CONTAMINATION OF
RESIN & HARDENER. LARGE MASSES OF MIXED RESIN & HARDENER MAY SELF-IGNIT
Materials To Avoid: STRONG OXIDIZING AGENTS, STRONG ACIDS, STRONG BASES
Hazardous Decomposition Products: ALDEHYDES, ACIDS, CARBON MONOXIDE, CARBON
DIOXIDE
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: EXCESSIVELY LARGE MASSES OF MIXED RESIN &
AMINES. STRONG OXIDIZING AGENTS OR BASES. NO PROBLEM UNDER NORM. USAGE
CONDITN
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 109312
Product ID: EPOLITE 3300-3301 RESIN
Review Date: 09/28/1994
Tech Entry NOS Shipping Nm: TETRAETHYLENEPENTAMINE, TRIETHYLENETETRAMINE
Net Unit Weight: 100.1 LBS
Multiple KIT Number: 0
Kit Part IND: Y
Review IND: Y
Type Of Container: UNKNOWN
Additional Data: NOTE: SHIPPING IS GIVEN FOR THE KIT WHICH CONTAINS A CORROSIVE
HARDENER. IF THE RESIN IS SHIPPED ALO NE, IT IS NOT REGULATED.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DWG
Symbols: G
DOT Proper Shipping Name: CORROSIVE LIQUIDS, N.O.S.
Hazard Class: 8
UN ID Num: UN1760
DOT Packaging Group: III
Label: CORROSIVE
Special Provision: T7
Non Bulk Pack: 203
Bulk Pack: 241
Max Qty Pass: 5 L
Max Qty Cargo: 60 L
Vessel Stow Req: A
Water/Ship/Other Req: 40
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ESH
IMO Proper Shipping Name: CORROSIVE LIQUID, N.O.S. o
IMDG Page Number: 8147
UN Number: 1760
UN Hazard Class: 8
IMO Packaging Group: I/II/III
Subsidiary Risk Label: -
EMS Number: 8-15
MED First Aid Guide NUM: 760
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: HKW
IATA UN ID Num: 1760
IATA Proper Shipping Name: CORROSIVE LIQUID, N.O.S. *
IATA UN Class: 8
IATA Label: CORROSIVE
UN Packing Group: III
Packing Note Passenger: 818
Max Quant Pass: 5L
Max Quant Cargo: 60L
Packaging Note Cargo: 820
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: HKW
AFI Symbols: *
AFI Proper Shipping Name: CORROSIVE LIQUID, N.O.S.
AFI Hazard Class: 8
AFI UN ID NUM: UN1760
AFI Packing Group: III
Special Provisions: P5
Back Pack Reference: A12.3
=======================================================
HAZCOM Label
=======================================================
Product ID: EPOLITE 3300-3301 RESIN
Cage: MO998
Assigned IND: Y
Company Name: HEXCEL CORP.-CHEMICAL PRODUCTS DIV.
Street: 20701 NORDHOFF STREET
PO Box: 2197
Zipcode: 91311
Label Required IND: Y
Date Of Label Review: 09/28/1994
Status Code: C
MFG Label NO: UNKNOWN
Label Date: 09/28/1994
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE- SKIN CONTACT MAY CAUSE IRRITATION.
REPEATED/PROLONGED EXPOSURE CAN CAUSE DERMATITIS & SKIN SENSITIZATION.
INGESTION MAY CAUSE GI TRACT BURNING. VAPORS ARE EXCEEDINGLY IRRITATING TO
MUCOUS MEMBR ANES & EYES. CHRONIC- DERMATITIS. TARGET ORGANS:EYES, SKIN,
RESPIRATORY & GI TRACTS. KEEP IN TIGHTLY CLOSED CONTAINERS. ABSORB SPILLS
WITH SAND/SAWDUST. FIRST AID- GET MEDICAL ATTENTION IF SYMPTOMS PE RSIST.
SKIN:WASH WITH SOAP & WATER. EYE:FLUSH WITH WATER FOR 15 MINUTES, HOLDING
EYELIDS OPEN. INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF NEEDED.
ORAL:GET MEDICAL ATTENTION IMMEDIATELY. INDUC E VOMITING ONLY UPON THE ADVICE
OF A PHYSICIAN.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CAREFREE RECHARGEABLE BATTERY
CAGE:0B3X4
CAGE:0B3X4
CAGE:81855
CAGE:60463
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 50% %
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LEAD OXIDES
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 25% %
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG(PB)/M3
ACGIH TLV:0.15MG(PB)/M3;DUST92
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SULFURIC ACID (SARA III), (38% SULFURIC ACID, 1.28 SP GR)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 18% %
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS AN ARTICLE UNDER OSHA WHICH
UNDER NORMAL USE IS NON-HAZARDOUS. HOWEVER UNDER CERTAIN UNUSUAL
CONDITIONS PERSONS MAY BE EXPOSED TO TOXIC LEAD,CORROSIVE SULFURIC
ACID AND/OR EXPLOSIVE HYDROGE N.SEVERE BURNS AND EYE DAMAGE MAY
RESULT FROM EXPOSURE TO SULFURIC ACID ELECTROLYTE AND ILLNESS FROM
SULFUR OXIDE FUMES.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:IRRITATION AND ACID BURNS. PUNGENT ODOR AND
RESPIRATORY IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH AREA WITH SOAP
AND WATER. GET MEDICAL ATTENTION. INHALATION: MOVE TO FRESH AIR.
GET MEDICAL ATT ENTION. INGESTION: LEAD/LEAD COMPOUNDS:GET MEDICAL
ATTENTION. SULFURIC ACID:DO NOT INDUCE VOMITING.GIVE WATER OR MILK
FOLLOWED BY MILK OF MAGNESIA,BEATEN EGGS OR VEGETABLE OIL. GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:EXPLOSION CAN RESULT FROM IMPROPER
CHARGING AND IGNITION OF CHARGING GASES; ALSO IF CHARGED IN GAS
TIGHT ENCLOSURES. KEEP LIGHTED CIGARETTES,SPARKS,FLAMES AWAY.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CONTACT WITH SULFURIC ACID ELECTROLYTE
FROM BATTERY. NEUTRALIZE WITH SOLUTION OF BAKING SODA IN WATER.
COLLECT NEUTRALIZED WASTE IN A SUITABLE CONTAINER FOR DISPOSAL. DO
NOT FLUSH LEAD CONTAMINA TED ACID TO SEWER.
Neutralizing Agent:BAKING SODA IN WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA WITH IMPERVIOUS SURFACES AND ADEQUATE SPILL CONTAINMENT.
BATTERIES SHOULD BE STORED UNDER ROOF.
Other Precautions:SEAL BATTERIES WITH RELEASED ELECTROLYTE IN
POLYETHYLENE BAGS. AVOID PHYSICAL DAMAGE TO CONTAINERS. KEEP AWAY
FROM FIRE, SPARKS, AND HEAT. DO NOT OVERCHARGE. DO NOT SHORT
CIRCUIT BATTERY TERMINALS.KEE P BAKING SODA IN AREA FOR EMERGENCY
USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. WHEN CONCENTRATIONS OF
SULFURIC ACID MIST ARE KNOWN TO EXCEED PEL, USE NIOSH OR
MSHA-APPROVED RESPIRATORY PROTECTION.
Ventilation:LOCAL EXHAUST IS RECOMMENDED AT CHARGING STATIONS AND WHERE
PEL IS EXCEEDED. VENTIL. COMPONENTS MUST BE ACID-RESISTANT.
Other Protective Equipment:HAVE EYE WASH STATION AND SAFETY SHOWER
AVAILABLE. ACID-RESISTANT APRON, BOOTS, AND PROTECTIVE CLOTHING FOR
MAJOR SPILL.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SOLVENTS MAY DISSOLVE BATTERY CASE.
Stability Condition to Avoid:EXTREME HEAT, SPARKS, OPEN FLAMES AND
OVERCHARGING OF BATTERY.
Hazardous Decomposition Products:SEVERE OVERCHARGING AND OVERHEATING
MAY CAUSE SULFUR OXIDE FUMES AND GENERATION OF FLAMMABLE HYDROGEN
GAS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. UNLAWFUL TO DISPOSE IN LANDFILL. DO NOT
INCINERATE,PUNCTURE,DISASSEMBLE OR MUTILATE. SEND SPENT BATTERIES
TO LEAD SMELTER FOR RECYCLE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:OIL OF VITRIOL, SX1244TP
CAGE:DO242
CAGE:63612
CAGE:DO242
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID (SARA 302/313) (CERCLA)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 100%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/3 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUPDAT:FOLLOWING EM SCIENCE SPILL-X NEUTRALIZER & ABSORB IS
RECOMMENDED FOR THIS PROD:SX0861 ACID SPILL TREATMENT KIT.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:(SEE SFTY EQUIP SUPPLIER). ENGINEERING AND/OR
ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE EXPOS.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 2140 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAUSES SEVERE BURNS ON CONTACT
WITH ANY BODY TISSUE. POSSIBLY FATAL BY INHALATION OR INGESTION.
INHALATION OF MIST MAY DAMAGE RESPIRATORY TRACT AND LUNGS.
Explanation of Carcinogenicity:SULFURIC ACID:IARC MONO ON EVAL OF
CARCIN RISK OF CHEMS TO MAN, VOL 54, PG 41, 1992:GROUP 1.
ANIMAL:PULMONARY IRRIT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS.
======================= First Aid Measures =======================
First Aid:GET MED ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. INGEST:DO
NOT INDUCE VOMIT; DILUTE BY GIVING MILK/WATER IF CONSCIOUS; GET MED
ATTN IMMED. SKIN:FLUSH THOROUGHLY W/WATER; REMOVE ALL CONTAMD CLTHG
& SH OES; GET IMMED MED ATTN. EYES:FLUSH W/WATER FOR @ LST 15 MINS,
LIFTING UPPER & LOWER LIDS OCCASNLY; CONTINUE FLUSHING WHILE
WAITING FOR MED HELP. INHAL:REMOVE TO FRESH AIR; GET IMMED MED
ASSISTANCE.
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:DRY CHEMICAL OR SAND; DO NOT USE WATER OF FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:REACTS WITH MOST METALS TO FORM EXPLOSIVE
HYDROGEN GAS WHICH CAN FORM EXPLOSIVE MIXTURES WITH AIR. MAY IGNITE
COMBUSTIBLE MATERIAL ON CONTACT.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC AREA OF ALL UNNEC PERS. WEAR SUITABLE
PROT EQUIP LISTED UNDER EXPOS/PERSONAL PROT. ELIM ANY IGNIT SOURCES
UNTIL AREA IS DETERM TO BE FREE FROM EXPLOSION/FIRE HAZS. CONTAIN
RELEASE & ELIM ITS SOUR CE, IF THIS CAN BE DONE W/OUT RISK.
(SUPDAT)
Neutralizing Agent:SPILL-X NEUTRALIZERS & ABSORB AGENTS FOR VARIOUS
TYPES OF SPILLS. ADDNL (SUPDAT)
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR CLSD & PROTECTED AGAINST
PHYSICAL DMG. KEEP UPRIGHT; SEPARATE FROM ALL INCOMPAT MATLS,
COMBUST MATLS & OXIDIZING AGENTS.
Other Precautions:DO NOT BREATHE VAPOR. DO NOT GET IN EYES, ON SKIN, OR
ON CLOTHING. RETAINED RESIDUE MAY MAKE EMPTY CONTAINERS HAZARDOUS;
USE CAUTION! CAUSES SEVERE BURNS. MAY BE FATAL IF INHALED OR
SWALLOWED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKPLACE EXPOS LIMIT(S) OF PROD/ANY
COMPONENT IS EXCEEDED (SEE TLV/PEL), NIOSH APPRVD AIR SUPPLIED RESP
IS ADVISED IN ABSENCE OF PROPER ENVIR CTL. OSHA REGS ALSO PERMIT
OTHER NIOSH RESPS (NEG PRES S TYPE) UNDER SPECIFIED CNDTNS (ING 3)
Ventilation:MATL MUST BE HNDLD OR TRANSFERRED IN APPRVD FUME HOOD OR
WITH EQUIVALENT VENTILATION.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . PROT
CLTHG (NATURAL RUBB, NEOPRENE/EQUIV) MUST BE WORN TO PVNT SKIN
CONT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
SPILL PROC:TAKE UP & CONTAINERIZE FOR PROPER DISP AS DESCRIBED UNDER
DISP. COMPLY W/FED, STATE, & LOC REGS ON RPTG RELEASES. REFER TO
REGULATORY INFO FOR REPORTABLE QTY & OTHER REGULATORY DATA. NEUT A
GENT:INFO ON SPILL-X PRODS CAN BE PROVIDED THRU EM SCIENCE
TECHNICAL SERVICE DEPARTMENT (609)354-9200. THE (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>554F,>290C
Melt/Freeze Pt:M.P/F.P Text:14F,-10C
Vapor Pres:1 @ 146C
Spec Gravity:1.844 (H*2O=1)
Evaporation Rate & Reference:<1 (BUAC =1)
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS VISCOUS LIQUID; SHARP ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, BASES, OXIDIZERS, REDUCING AGENTS, METAL POWDERS, CARBIDES,
ACETIC ACID, COMBUSTIBLE MATERIAL.
Stability Condition to Avoid:ADDING WATER TO ACID CAN CAUSE VIOLENT,
EXOTHERMIC REACTION, POSSIBLY CAUSING FIRE. CAN REACT VIOLENTLY
W/ALKALIES.
Hazardous Decomposition Products:SO*X, HYDROGEN (IN PRESENCE OF
METALS).
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE NO:D002. TREATMENT:SPECIFIED
TECHNOLOGY-NEUT TO PH 6-9. CONT LOC PERMITTED WASTE DISP SITE (TSD)
FOR PERMISSIBLE TREATMENT SITES. ALWAYS CONT PERMITTED WASTE
DISPOSER (TSC) TO ASSURE COMPLIA NCE W/ALL CURRENT LOC, STATE &
FEDERAL REGS.
| 1 | gloves_mandatory |
=======================================================
Product ID: ZYTEL NYLON RESINS, ZYTEL 70G30HSL BK139
Cage: 9V583
Resp. Party Other MSDS No.: ZYT007
=======================================================
Contractor Summary
=======================================================
Cage: 9V583
=======================================================
Ingredients
=======================================================
< Wt: 35.
Other REC Limits: 5 MG/M3 TOTAL DUST
OSHA PEL: NONE ESTABLISHED
ACGIH TLV: 5MG/M3, 8HR TWA
-----------------------------
< Wt: 4.
-----------------------------
Cas: 32131-17-2
> Wt: 65.
Other REC Limits: 10 MG/M3; 5 MG/M3 RE
OSHA PEL: NONE ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ADDITIONAL HEALTH EFFECTS: READ "ZYTEL" MOLDING GUIDE
BEFORE USING THIS PRODUCT. POLYHEXAMETHYLENE ADIPAMIDE: IN GENERAL SKIN
IRRITATION HAS NOT BEEN PRODUCED IN HUMAN PATCH TESTS WITH NYLON 66. HOWEV
ER, A SMALL PERCENTAGE OF SUBJECTS MAY RESPOND TO PROLONGED CONTACT WITH
REDNESS OF SKIN. SIGNIFICANT SKIN PERMEATION AND SYSTEMIC TOXICITY AFTER
CONTACT APPEARS UNLIKELY. THERE ARE NO REPORTS OF HUMA N SENSITIZATION. IF
PARTICLES OF NYLON 66 CONTACT THE EYE, MECHANICAL IRRITATION WITH TEARING,
PAIN OR BLURRED VISION MAY RESULT. FIBERGLASS: THE MECHANICAL ACTION OF THE
SHARP FIBERS FROM FIBERGLAS S MAY (SIGNS & SYMPTOMS OF OVEREXPOSURE)
Explanation Of Carcinogenicity: NONE OF COMPONENTS PRESENT IN THIS MATERIAL AT
CONCENTRATIONS EQUAL TO OR GREATER THAN 0.1% ARE LISTED BY IARC, NTP, OSHA OR
ACGIH AS A CARCINOGEN.
Signs And Symptions Of Overexposure: HEALTH HAZARDS ACUTE AND CHRONIC (CONT):
CAUSE SKIN IRRITATION WITH DISCOMFORT OR RASH. INHALATION OF FIBERGLASS
PARTICLES MAY CAUSE IRRITATION OF THE UPPER RESPIRATORY PASSAGES, WITH
COUGHING AND DIS COMFORT. RESULTS FROM EPIDEMIOLOGY STUDIES SUGGEST NO LINK
BETWEEN FIBERGLASS EXPOSURE AND CANCER. ONE EPIDEMIOLOGY STUDY INDICATES
SLIGHT INCREASE IN LUNG CANCER DEATHS. THE EVIDENCE THAT FIBERGLASS IS
RELATED TO THESE INCREASED LUNG CANCER DEATHS IS CONSIDERED WEAK.
Medical Cond Aggravated By Exposure: INDIVIDUALS WITH PRE-EXISTING DISEASES OF
LUNGS MAY HAVE INCREASED SUSCEPTIBILITY TO TOXICITY OF EXCESSIVE EXPOSURES.
First Aid: INHALATION: NO SPECIFIC INTERVENTION IS INDICATED AS THE COMPOUND IS
NOT LIKELY TO BE HAZARDOUS BY INHALATION. CONSULT A PHYSICIAN IF NECESSARY.
IF EXPOSED TO FUMES FROM OVERHEATING OR COMBUSTION, MOV E TO FRESH AIR.
CONSULT PHYSICIAN IF SYMPTOMS PERSIST. SKIN CONTACT: THE COMPOUND IS NOT
LIKELY TO BE HAZARDOUS BY SKIN CONTACT, BUT CLEANSING THE SKIN AFTER EACH USE
IS ADVISABLE. IF MOLTEN POLYMER GETS ON SKIN, COOL RAPIDLY WITH COLD WATER.
DO NOT ATTEMPT TO PEEL POLYMER FRM SKIN. OBTAIN MEDICAL TREATMENT FOR THERMAL
BURN. EYE CONTACT: IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES WITH PLENTY OF
W ATER FOR (SUPPLEMENTAL SAFETY & HEALTH)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SAFEGUARDS (PERSONNEL): NOTE: REVIEW FIRE FIGHTING
MEASURES/HANDLING (PERSONNEL) SECTIONS BEFORE PROCEEDING WITH CLEAN-UP. USE
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT DURING CLEAN-UP. SPILL CLEAN UP:
SWEEP UP TO AVOID SLIPPING HAZARD.
Waste Disposal Methods: PREFERRED OPTIONS: RECYCLING, INCINERATION WITH ENERGY
RECOVERYAND LANDFILL. HIGH FUEL VALUE OF PRODUCT MAKES OPTION OF INCINERATION
VERY DESIRABLE FOR MATERIAL THAT CANNOT BE RECYCLED. TREATMENT, STO RAGE,
TRANSPORTATION AND DISPOSAL MUST BE IN ACCORDANCE WITH APPLICABLE FEDERAL,
STATE/PROVINCIAL A ND LOCAL REGULATIONS.
Handling And Storage Precautions: HANDLING: SEE FIRST AID AND PERSONAL
PROTECTIVE EQUIPMENT SECTIONS. STORAGE: STORE IN COOL, DRY PLACE. KEEP
CONTAINERS TIGHTLY CLOSED TO PREVENT MOISTURE ABSORPTION AND CONTAMINATION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point: =400.C, 752.F
Flash Point Text: METHOD: D1929
Extinguishing Media: WATER, FOAM, DRY CHEMICAL, CO2.
Fire Fighting Procedures: KEEP PERSONNEL UPWIND OF FIRE. WEAR SELF-CONTAINED
BREATHING APPARATUS (NIOSH APPROVED - FP N).
Unusual Fire/Explosion Hazard: LARGE MOLTEN MASSES MAY IGNITE SPONTANEOUSLY IN
AIR. WATER QUENCHING OF SUCH MASSES IS GOOD PRACTICE. HAZARDOUS GASES/VAPORS
PRODUCED IN FIRE ARE AMMONIA, CARBON MONOXIDE, SMALL AMOUNTS OF HYDROGEN CY
ANIDE, AND ALDEHYDES.
=======================================================
Control Measures
=======================================================
Respiratory Protection: A NIOSH APPROVED AIR PURIFYING RESP WITH AN ORGANIC
VAPOR CARTRIDGE WITH A DUST/MIST FILTER WHEN AIRBORNE CONCENTRATIONS EXPECTED
TO EXCEED EXPOSURE LIMITS. USE POSITIVE-PRESSURE AIR SUPPLIED RESP IF ANY
POTENTIAL FOR UNCONTROLLED RELEASE, EXPOS LEVELS NOT KNOWN OR ANY OTHER
CIRCUMSTANCES WHERE AIR-PURIFYING RESPIRATORS MAY NOT PROVIDE ADEQUATE
PROTECTION.
Ventilation: USE LOCAL EXHAUST TO COMPLETELY REMOVE VAPORS, FUMES AND
PLASTICIZER LIBERATED DURING HOT PROCESSING FROM THE WORK AREA.
HYGENIC PRACTICES)
Other Protective Equipment: EYEWASH AND DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N). IF THERE IS POTENTIAL FOR CONTACT WITH HOT / MOLTEN
MATERIAL, WEAR HEAT RESISTANT CLOTHING AND FOOTWEAR.
FOR EYE AND FACE CONTACT DUE TO SPLASHING OR SPRAYING OF MOLTEN MATERIAL.
Supplemental Safety and Health: FIRST AID (CONT): AT LEAST 15 MINUTES. CALL A
PHYSICIAN. INGESTION: NO SPECIFIC INTERVENTION IS INDICATED AS COMPOUND IS
NOT LIKELY TO BE HAZARDOUS BY INGESTION. CONSULT A PHYSICIAN IF NECESSARY.
=======================================================
Physical/Chemical Properties
=======================================================
Melt/Freeze Pt: =250.C, 482.F
M.P/F.P Text: 250-260C (482-500F) NE
Spec Gravity: 1.22 - 1.38
Solubility in Water: INSOLUBLE
Appearance and Odor: GRANULES, NO ODOR.
Percent Volatiles by Volume: CA 1%- WATER
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: STABLE AT NORMAL TEMPERATURES AND STORAGE
CONDITIONS.CONDITIONS TO AVOID: TEMPERATURES ABOVE 340C (644F).
Materials To Avoid: INCOMPATIBLE OR CAN REACT WITH STRONG ACIDS, OXIDIZING
AGENTS.
Hazardous Decomposition Products: CYCLOPENTANONE, CARBON MONOXIDE, ALDEHYDES
AND AMMONIA.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
Toxicological Information: ANIMAL DATA: NYLON 66-ORAL LD50, RAT: >10,000
MG/KG. NYLON 66 IS NOT A SKIN IRRITANT IN TESTS WITH ANIMALS. SINGLE
EXPOSURE BY INGESTION TO HIGH DOSES CAUSED DECREASED BODY WEIGHT. LONG-TERM
EXPOSURE CAUSED NO SIGNIFICANT TOXICOLOGICAL EFFECTS. REPEATED INHALATION
EXPOSURE CAUSED HISTOPATHOLOGICAL CHANGES OF THE LUNGS, & KIDNEYS. IN
ANIMAL TESTING, NYLON 66 HAS NOT CAUSED CARCINOGENICITY. NO ANIM AL DATA ARE
AVAILABLE TO DEFINE DEVELOPMENTAL, REPRODUCTIVE OR MUTAGENIC HAZARDS.
FIBERGLASS: SKIN IRRITATION AND MILD EYE IRRITATION OCCURRED IN ANIMALS, BUT
EFFECTS ATTRIBUTED TO MECHANICAL DAMAGE RATHER THAN CHEMICAL (TRANSPORT
INFO)
=======================================================
Ecological Information
=======================================================
Ecological: AQUATIC TOXICITY: NO INFO AVAILABLE. TOXICITY EXPECTED LOW BASED ON
INSOLUBILITY IN WATER. DO NOT DISCHARGE TO PONDS/STREAMS/LAKES/SEWERS.
PRODUCT ID (CONT): TRADENAMES/SYNONYMS: "ZYTEL" -- 54 29ER BK031, 70G3OHSL
BK099, 70G30HSL BK139, 70G3OHSL BK186. 70G30HSL NC010, 70G30HSLR BK099,
70G30HSR2 BK430, 70G30PSR NC010, 70G33HS1L BK031, 70G33HS1L BK031R, 70G33HS1L
BK104TP, 70G33HS1L BLB299, 70 G33HS1L GNB300, 70G33HS1L GYB255, 70G33HS1L
GYB265, 70G33HS1L GYB269, 70G33HS1L GYB519, 70G33HS1L GYB522, 70G33HS1L
NC010, 70G33HS1L NC010J, 70G33HS1L NC010P, 70G33HS1L YLB192, 7033HS1L RDB311,
70G33L BK031, (SARA)
=======================================================
=======================================================
Transport Information: SHIPPING INFO: DOT-PROPER SHIPPING NAME: NOT REGULATED.
TDG: NOT REGULATED. TOXICOLOGICAL INFO (CONT) EFFECT. THE EFFECTS IN
MICE FROM SINGLE EXPOS BY INTRATRACHAEL INSTILLATION W/FIBERGLASS INCL
INFLAMMATORY RESPONSE. REPEATED INHAL EXPOS INVOKED PULMONARY MACROPHAGE
REACTIONS SIMILAR TO BIOLOGICALLY INERT DUSTS. TESTS IN SOME ANIMALS
DEMONSTRATE CARCINOGENIC ACTIVITY. STUDIES WERE BY ARTF I
MPLANTATION/INJECTION OF FINE GLASS FIBERS INTO CHEST/ABDOMINAL
CAVITY/TRACHEA & JUDGED TO BE IRRELEVANT TO INDUST. EXPOS. CHRONIC INHAL
EXPOS OF ANIMALS AT LOW CONCENTRATIONS PRODUCED MINIMAL FIBROSI S IN (STATE
REG)
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: MATERIAL IS NOT KNOWN TO CONTAIN TOXIC CHEMICALS
UNDER SECTION 313 OF SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND
40 CFR PART 372. ECOLOGICAL INFO (CONT): 70G33L NC010, 70G35HS1L
BK031R, FE5105 NC010, FE5329 NC010, FE5354 BK031, FE423 NC010, FE5468 NC010,
FE15005 BK033, "MARANYL" A475.
Federal Regulatory Information: TSCA INVENTORY STATUS: ALL COMPONENTS IN
COMPLIANCE WITH TSCA INVENTORY REQUIREMENTS.
State Regulatory Information: STATE RIGHT-TO-KNOW LAWS: NO SUBSTANCES ON STATE
HAZ SUBST LIST PRESENT AT CONCENTRATION OF 1% OR MORE. FOR SPECIAL HAZ SUBST:
NONE KNOWN. SUBST ON NEW JERSEY WORKPLACE HAZ SUBST LIST PRESENT AT CONCE
NTRATION OF 1% OR MORE (0.1% FOR SUBSTANCES ID'D AS CARCINOGENS, MUTAGENS OR
TERATOGENS): NONE KNOWN. TRANSPORT INFO (CONT): ONE STUDY & NO
ADVERSE EFFECTS IN DIFFERENT STUDY. NO ANIMAL TEST REP ORTS AVAIL TO DEFINE
MUTAGENIC/DEVELOPMENTAL/REPRODUCTIVE HAZARDS. RESPONSIBILITY FOR MSDS: J.
P. BOLLMEIER. DUPONT ENGINEERING POLYMERS. CHESTNUT RUN PLAZA 713.
WILMINGTON, DE 19880-0713. TEL 302-999-4257.
=======================================================
Other Information
=======================================================
Other Information:: HEALTH -2, FIRE -1, REACTIVITY -0. EXPOSURE LIMITS: "ZYTEL"
NYLON RESINS IN SYNONYM LIST OF ZYT007-PEL (OSHA): PARTICULATES (NOT
OTHERWISE REGULATED) 15 MG/M3, 8 HR TWA, TOTAL DUST. 5 MG/M3, 8 H R TWA,
RESPIRABLE DUST. POLYHEXAMETHYLENE ADIPAMIDE: AEL(DUPONT)-10 MG/M3, 8 HR TWA,
TOTAL DUST. 5 MG/M3, 8 HR TWA, RESPIRABLE DUST. SHORT GLASS FIBERS: AEL
(DUPONT)-5 MG/M3 TOTAL DUST-8 HR TWA, NON-R ESPIRABLE FIBER (>3 MICRONS IN
DIAMETER) NON-FIBROUS PARTICULATE. AEL IS DUPONT'S ACCEPTABLE EXPOSURE LIMIT.
WHERE GOVERNMENTALLY IMPOSED OCCUPATIONAL EXPOS LIMITS WHICH ARE LOWER THAN
AEL ARE IN EFFE CT, SUCH LIMITS SHALL TAKE PRECEDENCE.
=======================================================
HAZCOM Label
=======================================================
Product ID: ZYTEL NYLON RESINS, ZYTEL 70G30HSL BK139
Cage: 9V583
Company Name: DUPONT E I DE NEMOURS AND CO INC, POLYMER PRODUCT-TEFLON CO.
Street: 1007 MARKET ST
Zipcode: 19898
Label Required IND: Y
Date Of Label Review: 01/24/2001
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: MAY CAUSE SKIN IRRITATION WITH DISCOMFORT OR
RASH. PROLONGED CONTACT MAY CAUSE REDNESS OF SKIN. SIGNIFICANT SKIN
PERMEATION AND SYSTEMIC TOXICITY AFTER CONTACT APPEARS UNLIKELY. THERE ARE NO
RE PORTS OF HUMAN SENSITIZATION. IF PARTICLES CONTACT THE EYE, MECHANICAL
IRRITATION WITH TEARING, PAIN OR BLURRED VISION MAY RESULT. INHALATION OF
FIBERGLASS PARTICLES MAY CAUSE IRRITATION OF THE UPPER RESPIRATORY PASSAGES
WITH COUGHING AND DISCOMFORT. CHRONIC: NONE SPECIFIED BY MANUFACTURER (FP N).
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COLORING AGENTS, 505
CAGE:18731
CAGE:18731
============= Composition/Information on Ingredients =============
Ingred Name:2-PENTANONE, 4-HYDROXY-4-METHYL-; (DIACETONE ALCOHOL)
CAS:123-42-2
RTECS #:SA9100000
Fraction by Wt: 15-30%
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: IRRITATION, BURNING,
TEARING, REDNESS AND SWELLING. SKIN: IRRITATION. PROLONGED OR
REPEATED CONTACT MAY CAUSE BURNING, DRYING, AND CRACKING. INHAL:
IRRITATION OF NOSE AND THROAT, DROWSINE SS AND FATIGUE. CHRONIC:
NONE ESTABLISHED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET MED ATTN. SKIN: WASH WITH SOAP AND WATER. INHAL:
REMOVE PERSON TO FRESH AIR. INGEST: GET MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:146F,63C
Lower Limits:1.8%
Extinguishing Media:CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP AND WASH AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS
AWAY FROM SOURCES OF HEAT OR IGNITION. AVOID PROLONGED OR REPEATED
CONTACT WITH SKIN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:MECHANICAL VENT TO MAINTAIN BELOW EXPOSURE LIMITS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:295F,146C
Vapor Pres:1 @ 20C
Vapor Density:HVR/AIR
Spec Gravity:0.939
Evaporation Rate & Reference:0.18 (BUAC=1)
Solubility in Water:<60%
Appearance and Odor:VARIOUS COLORS, MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT APPLICABLE.
Stability Condition to Avoid:SOURCES OF IGNITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL QUANTITIES MAY BE DILUTED WITH WATER AND
FLUSHED TO A SEWER. DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL
REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WASP & HORNET SPRAY, 75679
CAGE:5L381
CAGE:5L381
============= Composition/Information on Ingredients =============
Ingred Name:PYRETHRUM; (PYRETHRINS)
CAS:8003-34-7
RTECS #:UR4200000
Fraction by Wt: 0.077%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TOLUENE,
ALPHA-(2-(2-BUTOXYETHOXY)ETHOXY)-4,5-(METHYLENEDIOXY)-2-PROPYL-;
(PIPERONYL BUTOXIDE)
CAS:51-03-6
RTECS #:XS5805000
Fraction by Wt: 0.193%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (PETROLEUM DISTILLATE).
LEL: 0.6%
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 25%
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:CARBAMIC ACID, METHYL, 1-NAPHTHYL ESTER; (CARBARYL)
CAS:63-25-2
RTECS #:FC5950000
Fraction by Wt: 0.515%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ETHANE, 1,1,1-TRICHLORO; (METHYL CHLOROFORM). LEL: 7.5%
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 55%
OSHA PEL:350 PPM;450 STEL
ACGIH TLV:350 PPM;450 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:METHANE, DICHLORO-; (METHYLENE CHLORIDE)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 15%
OSHA PEL:500 PPM,C
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: <5%
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM;30000 STEL
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:REPORTS HAVE ASSOCIATED RPTD & PRLNGD
OVEREXP TO SOLV W/PERM BRAIN & NERV SYS DAM. ALSO KIDNEY & LIVER
DAM. PURSUANT TO PROPOSITION 65: CERTAIN RAW MATLS USED IN MAKING
PROD MAY CNTN SM AMTS OF MATLS AS IMPURITIES WHICH ARE REGULATED
BY PROPOSITION 65. IN A CONFINED AREA VAPS IN HIGH CONC ARE ANESTH.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: IARC MONOGRAPHS
SUPPLEMENT, VOL 7, PG 194, 1987: GRP 2B. NTP 6TH ANNUAL REPORT ON
CARCIN, (SUPDAT)
Effects of Overexposure:HLTH HAZ: IRRITANT TO SKIN & UPPER RESP SYS.
OVEREXP MAY RSLT IN LT-HEAD, STAGGER GAIT, GIDD, & POSS NAUS. CNTNS
PETROLEUM DISTILLATES-HARMFUL/FATAL IF SWALLOWED. CHLOROCARBON
MATLS HAVE PRDCD SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB
ANIMALS & COULD HAVE SIMILAR EFT IN HUMANS. ADRENOMIMETICS (SUPP
DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/WATER FOR AT LEAST 15 MINUTES. GET IMMED
MED ATTN. SKIN: PROMPTLY WASH CONTAMD SKIN W/SOAP & WATER. IF CLTHG
PENETRATED, REMOVE & WASH SKIN W/SOAP & WATER. GET PROMPT MED ATTN.
INH AL: MOVE TO FRESH AIR & PERFORM ARTF RESP IF BRTHG HAS STOPPED.
KEEP WARM & QUIET. GET MED ATTN. ASAP. INGEST: CALL PHYS IMMED. DO
NOT INDUCE VOMIT.
===================== Fire Fighting Measures =====================
Flash Point:170F,77C
Lower Limits:SEE INGRED
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL/FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESS DEMAND SCBA AND
FULL PROTECTIVE EQUIPMENT . WATER MAY BE INEFTIVE. WATER MAY BE
USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:DO NOT SPRAY NEAR OPEN FLAME. KEEP @
ROOM TEMP AS EXPOS TO DIRECT SUNLIGHT/OTHER HEAT MAY CAUSE
BURSTING. THERMAL DECOMP PROD MAY INCL HCL & PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE,
AVOID BREATHING VAPORS, AND REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. KEEP AT ROOM
TEMPERATURE AS EXPOSURE TO DIRECT SUNLIGHT OR HEAT MAY CAUSE
BURSTING.
Other Precautions:KEEP AWAY FROM CHILDREN. DO NOT PUNCT/INCIN. DO NOT
SPRAY NEAR FIRE/OPEN FLAME. NO SMOKING IN AREA OF USE. DO NOT USE
IN GEN VICIN OF ARC WELD, OPEN FLAMES/HOT SURF. HEAT &/OR UV RADIA
MAY CAUSE FORM OF HCL &/OR PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BREATHING OF VAPOR/SPRAY MIST. USE
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN
.
Ventilation:LOC EXHST: PROVIDE LOC EXHST VENT IN VOL & PATTERN TO KEEP
TLV OF ALL HAZ INGRED BELOW ACCEPTABLE &/OR STATED LIMIT.
Other Protective Equipment:WEAR APPROP EQUIP/CLTHG (APRON) TO PVNT
RPTD/PRLNGD SKIN CONT. EMPLOYEES SHOULD WASH PROMPTLY WHEN SKIN
BECOMES(SUPDAT)
Work Hygienic Practices:FOLLOW CAUTIONS ON PRODUCT LABEL, USE
REASONABLE CARE AND PRACTICE GOOD HABITS OF CLEANLINESS.
Supplemental Safety and Health
EXPLAN OF CARCIN:1991: ANTIC TO BE CARCIN. ANIMAL: BLADDER CANCER,
LIVER, SKIN EFTS. EFTS OF OVEREXP: (E.G., EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS ACUTELY
OR CH RONICALLY EXPOS TO CHLOROCARBONS . OTHER PROT EQUIP: WET.
PROMPTLY REMOVE NON-IMPERVIOUS CLTHG THAT BECOME WET.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER(ETHER=1)
Appearance and Odor:CLEAR/PRUDENT
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:DO NOT STORE ABOVE 120F.
Hazardous Decomposition Products:BY OPEN FLAME: CARBON MONOXIDE, CARBON
DIOXIDE, HYDROGEN CHLORIDE, AND PHOSGENE GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE-DISPOSE I/A/W LOCAL, STATE AND
FEDERAL REGULATIONS REGARDING POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DESI PAK
CAGE:9Z280
CAGE:9Z280
============= Composition/Information on Ingredients =============
Ingred Name:BENTONITE(INORGANIC CLAY)
CAS:1302-78-9
RTECS #:CT9450000
Fraction by Wt: > 98%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (DUST)
ACGIH TLV:5 MG/M3 (DUST)
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: < 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE-THIS MATERIAL,CLASSIFIED A
NUISANCE DUST,MAY CAUSE HEALTH HAZARDS IF INHALED,INGESTED/IN
CONTACT WITH EYES & SKIN.PROLONGED INHALATION MAY CAUSE UPPER
RESPIRATORY TRACT IRRITATION.IF LARGE AMOUN TS ARE
INGESTED,INTESTINAL DISORDERS MAY OCCUR.MAY CAUSE EYE AND SKIN
IRRITATION.CHRONIC-MAY CAUSE LUNG DAMAGE.
Explanation of Carcinogenicity:CONTAINS SILICA WHICH IS PROBABLY
CARCINOGENIC TO HUMAN.
Effects of Overexposure:THIS MATERIAL, CLASSIFIED A NUISANCE DUST, MAY
CAUSE HEALTH HAZARDS IF INHALED, INGESTED OR IN CONTACT WITH EYES &
SKIN. PROLONGED INHALATION MAY CAUSE UPPER RESPIRATORY TRACT
IRRITATION AND/OR LUNG D AMAGE. IF LARGE AMOUNTS ARE INGESTED,
INTESTINAL DISORDERS MAY OCCUR. MAY CAUSE EYE AND SKIN IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THE SUBSTANCE.
======================= First Aid Measures =======================
First Aid:CALL A DOCTOR IF SYMPTOMS PERSIST. EYE:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP &
WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED.
ORAL:I F LARGE AMOUNTS HAVE BEEN INGESTED & CONSCIOUS, INDUCE
VOMITING. CALL A PHYSICIAN/POISON CONTROL CENTER IMMEDIATELY.
STOMACH SIPHON MAY BE APPLIED. MILK AND FATTY ACIDS SHOULD BE
AVOIDED.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:DRY CHEMICAL, WATER SPRAY OR FOAM. FOR LARGER
FIRES, USE WATER SPRAY, FOG OR FOAM.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS IN + PRESSURE MODE.
COOL FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE AND EXPLOSION HAZARD WHEN
EXPOSED TO HEAT OR FLAME BY REACTION WITH INCOMPATIBLE SUBSTANCES.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN-UP PERSONNEL NEED PROTECTION AGAINST
AND/OR WET METHODS OF CLEANUP ARE PREFERRED. PLACE IN APPROPRIATE
CONTAINERS FOR DISPOSAL . AVOID RAISING DUST. CLAY IS SLIPPERY WHEN
WET.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-STORE IN TIGHTLY CLOSED
CONTAINER IN A DRY, WELL VENTILATED PLACE BELOW 115 DEGREE F.
ALWAYS RESEAL CONTAINER.
Other Precautions:KEEP THIS AND ALL CHEMICALS OUT OF REACH OF CHILDREN.
THIS PRODUCT FOR INDUSTRIAL USE ONLY. DO NOT GENERATE DUST. AVOID
BREATHING DUSTS OR FUMES. DO NOT GET IN EYES, ON SKIN OR ON
CLOTHING. WASH THORO UGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A PROPERLY FITTED NIOSH-APPROVED DUST
RESPIRATOR IF CONDITIONS ARE DUSTY.
Ventilation:LOCAL AND/OR GENERAL EXHAUST VENTILATION
Other Protective Equipment:EYE WASH STATION, QUICK DRENCH SHOWER AND
IMPERVIOUS CLOTHING
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
THE MANUFACTURER STATES THAT THEY HAVE BOUGHT TRADE NAME OF CULLIGAN
AND LATER THEY USED UNITED DESICCANT TRADE NAME. WHEN CULLIGAN USA,
SAN BERNARDINO,CA, WAS CONTACTED TO OBTAIN A MSDS AT 909-887-25 57,
THEY REFERRED US TO UNITED DESICCANT (HMIS).
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:0.913 - 1.025
Solubility in Water:INSOLUBLE
Appearance and Odor:GRAY GRANULES - NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:STABLE UNDER NORMAL TEMPERATURES AND
PRESSURES IN SEALED CONTAINERS.
Hazardous Decomposition Products:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE
CONTAINER OR LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL
COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. COVER
PROMPTLY TO AVOID BLOWING DUST. RECOVER METAL COMPONENTS IF
POSSIBLE.
| 1 | gloves_mandatory |
=======================================================
Product ID: 2239, SILICA STANDARD, 10 PPM TO 1000 PPM (SUPDAT)
Cage: 0MX47
=======================================================
Contractor Summary
=======================================================
Cage: 0MX47
=======================================================
Ingredients
=======================================================
Cas: 13517-24-3
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: BALANCE
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
ALKALI). DO NOT INDUCE VOMIT. GET MED AID AT ONCE.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50(ORAL,RAT):1280 MG/KG
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:SKIN CONTACT MAY RESULT IN IRRITATION AND REDNESS.
EYE CONTACT MAY RESULT IN REDNESS, PAIN, BLURRED VISION AND CORNEAL
EPITHELIAL DAMAGE AT HIGHER CONCENTRATIONS. INGESTION OF HIGHER CONCENTRATI
ON OF SODIUM SILICATE CAN RESULT IN BURNING, PERFORATION, PAIN OF THE
ESOPHAGUS AND ABDOMEN; NAUSEA, (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZS:VOMITING, SHOCK, HYPOTENSION AND
CONSTIPATION MAY FOLLOW. CHRONIC:DERMATITIS, CONJUNCTIVITIS MAY OCCUR. NO
TOXIC EFFECTS ANTICIPATED AT THIS LEVEL OF SODIUM SILICATE CONCENTRATION.
SODIUM SI LICATE IS A SEVERE EYE, SKIN, AND MUCOUS MEMBRANE IRRITANT.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL:MOVE TO FRESH AIR, GIVE ARTF RESP IF NEC. MAINTAIN AIRWAY, MED
PERS MAY GIVE OXYG, KEEP WARM, AT REST. GET MED AID IMMED. SKIN:REMOVE CONTAM
CLTHG, WASH AREA W/SOAP & WATER. FLUSH W/LG AMTS OF W ATER (15-20 MIN)
UNTIL CHEM IS GONE. COVER CHEM BURNS W/DRY STERILE DRESSING. GET MED AID AT
ONCE. EYES:FLUSH W/LG AMTS OF WATER @ LST 15 MIN, LIFTING LIDS OCCCAS UNTIL
CHEM IS GONE. COVER(SUPP DATA)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ABSORB WITH VERMICULITE, DIATOMACEOUS EARTH, OR OTHER
SUITABLE ABSORBENT. SCOOP INTO CONTAINER AND LABEL FOR DISPOSAL. KEEP OUT OF
SEWERS AND DRAINS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
LAWS.
Handling And Storage Precautions: STORE CAPPED IN PLASTIC AT ROOM TEMPERATURE
PROTECTED FROM HEAT AND WATER REACTIVE SUBSTANCES.
Other Precautions: DO NOT WEAR CONTACT LENSES WHEN WORKING WITH CHEMICALS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NON-FLAMMABLE
Extinguishing Media: DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). MOVE CONTAINER FROM FIRE AREA IF POSSIBLE, AVOID BREATHING
DUST OR VAPORS.
Unusual Fire/Explosion Hazard: NO ACUTE HAZARD. NEGLIGIBLE FIRE HAZARD WHEN
EXPOSED TO HEAT OR FLAME.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN (FP N). NOT REQUIRED FOR ROUTINE LABORATORY USE.
RESPIRATORS NOT REQUIRED.
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: EMERGENCY EYE WASH & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: MFR TRADE/PART #:SIO2 SILICONE STANDARD, 1000
PPM SI. VP:14 @ 20C (H*2O). CNDTNS (STAB):CORRODES ALUMINUM & ZINC.
STABLE UNDER NORMAL TEMPS & PRESS UP TO BOILING PT (212F). MATLS TO
AVOID:CORRODES ALU MINUM & ZINC. FIRST AID PROC:BURNS W/DRY STERILE
NON-MEDICATED DRESSING (LOOSELY). GET MED AID @ ONCE. INGEST:
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212F,100C
M.P/F.P Text: 32.0F,0.0C
Vapor Pres: SUPP DATA
Vapor Density: 0.7(H*2O)
Spec Gravity: 1.0
Solubility in Water: SOLUBLE
Appearance and Odor: CLEAR COLORLESS LIQUID, ODORLESS.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: WATER REACTIVE SUBSTANCES (OLEUM, SODIUM). SODIUM
SILICATE REACTS VIOLENTLY W/ACIDS, IGNITES W/FLUORINE, (SUPP DATA)
Materials To Avoid: WATER REACTIVE SUBSTANCES (OLEUM, SODIUM). SODIUM SILICATE
REACTS VIOLENTLY W/ACIDS, IGNITES W/FLUORINE, (SUPP DATA)
Hazardous Decomposition Products: NEGLIGIBLE HAZARD FROM THERMAL DECOMPOSITION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 2239, SILICA STANDARD, 10 PPM TO 1000 PPM (SUPDAT)
Cage: 0MX47
Company Name: LABCHEM,INC.
Street: 200 WILLIAM PITT WAY
Zipcode: 15238
Label Required IND: Y
Date Of Label Review: 05/16/1995
Status Code: C
Label Date: 05/16/1995
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:SKIN CONTACT MAY RESULT IN IRRITATION AND
REDNESS. EYE CONTACT MAY RESULT IN REDNESS, PAIN, BLURRED VISION AND CORNEAL
EPITHELIAL DAMAGE AT HIGHER CONCENTRATIONS. INGESTION OF HIGHER CONCENTRATI
ON OF SODIUM SILICATE CAN RESULT IN BURNING, PERFORATION, PAIN OF THE
ESOPHAGUS AND ABDOMEN; NAUSEA, VOMITING, SHOCK, HYPOTENSION AND CONSTIPATION
MAY FOLLOW. CHRONIC:DERMATITIS, CONJUNCTIVITIS MAY OC CUR.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRO-SEAL 776 PRIMER PART B
CAGE:83527
CAGE:83527
============= Composition/Information on Ingredients =============
Ingred Name:POLYISOCYANATE ADDUCT
Fraction by Wt: 50%
Ingred Name:CYCLOHEXANONE (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 50%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:MUC MEM IRRIT & TIGHTNESS OF CHEST, IRRIT OF
RESP TRACT, COUGHING,HDCH, SHORT BRTH. POSS ALLERGENIC
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/ SOAP & WATER FOR AT LEAST 5 MIN. EYES: FLUSH
W/WATER FOR 15 MIN, CONSULT EYE MD. INH: REMOVE TO UNCONTAM AREA;
ADMIN OXYGEN BY AUTHORIZED PERSON,IF NEC. INTERNAL: INDUCE VOMITING
& CONSU LT MD.
===================== Fire Fighting Measures =====================
Flash Point:114F TTC
Lower Limits:1.7
Extinguishing Media:WATER SPRAY, CO*2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BRTHNG APPAR FOR FUMES
================== Accidental Release Measures ==================
Spill Release Procedures:SPILLED CHEMICAL SHOULD BE COVERED W/SAWDUST &
TREATED W/DILUTE AMMONIUM HYDROXIDE OR ALCOHOL & WATER IN & OPEN
CONTAINER BEFORE DISPOSAL. (MFR RECM)
======================Handling and Storage ======================
Handling and Storage Precautions:MUST BE STORED IN TIGHTLY CLSD
CONTAINER & PROTECT FROM MOISTURE & FOREIGN MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA CANISTER TY GAS MASKS EQUIP FOR
ORGANIC VAP; SELF-CONT TY
Ventilation:LOC EXHST TO MAINTAIN VAPOR CONC BELOW TLV
Supplemental Safety and Health
PART B OF A TWO PART PRODUCT. VAPOR PRESSURE IS APPROX & MEASURED AT
25C.KEY:J1.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:310F
Vapor Pres:7
Vapor Density:3.4
Spec Gravity:1.00
Evaporation Rate & Reference:0.23 (N BUAC)
Solubility in Water:MODERATE
Appearance and Odor:AMBER LIQUID. KETONE ODOR
Percent Volatiles by Volume:52
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER,ALCOHOLS,STRONG BASES,METAL CMP,SURFACE ACTIVE MATRL
Conditions to Avoid Polymerization:MOISTURE & OTHER MATRL THAT REACTS
W/ ISOCYANATES
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE DISPOSAL SHOULD BE IAW FED, STATE & LOCAL
CODES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ETHANOL, 95% (SEE SUPPL)
CAGE:59896
Contract Num:MDA414-00-P-1174
CAGE:59896
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Minumum % Wt:88.
Maxumum % Wt:95.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9596
Ingred Name:METHANOL (SARA 313) (CERCLA)
CAS:108-10-1
RTECS #:SA9275000
= Wt:5.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 7,060 MG/KG (ETHANOL)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYES, LIVER, KIDNEYS,
NERVES. ACUTE: CONCENTRATIONS BELOW 1,000 PPM USUALLY PRODUCE NO
SIGNS OF INTOXICATION. EXPOSURE TO CONCENTRATIONS OVER 1,000 PPM
MAY CAUSE HEADACHE, IRRITATION OF THE EYES, NOSE, AND THROAT, AND
IF CONTINUED FOR AN HOUR, DROWSINESS AND LASSITUDE, LOSS OF
APPPETITE AND INABILITY TO CONCENTRATE.
Explanation of Carcinogenicity:NOT LISTED AS CAUSING CANCER BY IARC,
NTP, OR OSHA. ETHYL ALCOHOL: MUTATION DATA CITED. REPRODUCTIVE
EFFECTS CITED. TURMORIGENIC DATA CITED.
Effects of Overexposure:CONCENTRATIONS BELOW 1,000 PPM USUALLY PRODUCE
NO SIGNS OF INTOXICATION. EXPOSURE TO CONCENTRATIONS OVER 1,000 PPM
MAY CAUSE HEADACHE, IRRITATION OF THE EYES, NOSE AND THROAT, AND IF
CONTINUED FOR AN HOUR, DROWSINESS AND LASSITUDE, LOSS OF APPETITE
AND INABILITY TO CONCENTRATE.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS OF THE
SKIN, EYES, THROAT, LIVER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES, RAISING AND LOWERING
EYELIDS OCCASIONALLY.. GET MEDICAL ATTENTION IF IRRITATION
PERSISTS. SKIN: REMOVE CONTAMINATED CLOTHES. WASH EXPOSED SKIN
AREA THOROUGHLY F OR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION IF
IRRITATION PERSISTS. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
INHALATION: MOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING IS
DIFFICULT. GIVE ARTIFICIALRESPIRATION IF BREATHING HAS STOPPED.
GET MEDICAL ATTENTION. INGESTION: IF CONSCIOUS, GIVE PLENTY OF
WATER. GET IMMEDIATE MEDICAL ATTENTION OR CALL POISON CONTROL FOR
ASSISTANCE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:55F TO 61F
Lower Limits:3.3 ETHANOL
Upper Limits:19 ETHANOL
Extinguishing Media:USE DRY CHEMICAL, CARBON DIOXIDE OR
ALCOHOL-RESISTANT FOAM. WATER MAY BE INEFFECTIVE.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR FULL PROTECTIVE
EQUIPMENT AND NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE. VAPORS ARE HEAVIER
THAN AIR AND CAN TRAVEL DISTANCES TO IGNITION SOURCES AND FLASH
BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF SPILL. ELIMINATE ALL SOURCES
OF IGNITION. CONTAIN SPILLED MATERIAL. DILUTE TO NONFLAMMABLE
MIXTURE WITH WATER. CONTAIN AND COLLECT FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:THIS MATERIAL SHOULD BE KEPT IN AN
AREA SUITABLE FOR STORAGE OF FLAMMABLE LIQUIDS. BOND AND GROUND
CONTAINERS WHEN TRANSFERRING LIQUID.
Other Precautions:KEEP OXIDIZING MATERIALS AND STRONG ACIDS AWAY. WEAR
DURING CLEANUP PROCESS. TAKE CARE IN HANDLING EMPTY CONTAINERS AS
RESIDUE CAN P RESENT FIRE AND EXPLOSION HAZARDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA CHEMICAL CARTRIDGE RESPIRATOR
SHOULD BE WORN IF PEL OR TLV IS EXCEEDED.
Ventilation:LOCAL EXHAUST- FOR HIGH CONCENTRATIONS. MECHANICAL
(GENERAL) VENTILATION - REQUIRED. SPECIAL -. EXPLOSION PROOF IF
WITHIN EXPLOSION LIMITS.
ALL TIMES.
Other Protective Equipment:LAB COAT, EYE WASH STATION AND SAFETY
SHOWER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
95% ETHANOL / PART# 86-1281, 500ML.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:78CF ETHANOL
Vapor Pres:44 MMHG ETHANOL
Vapor Density:1.6 ETHANO
Spec Gravity:0.79-0.81
Evaporation Rate & Reference:5.9 (BUAC=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID WITH ALCOHOL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS. IN ADDITION, METHANOL MAY ATTACK SOME FORMS OF
PLASTIC.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:TO THE BEST OF OUR KNOWLEDGE, THE
TOXICOLOGICAL PROPERTIES OF THIS MIXTURE HAVE NOT BEEN THROUGHLY
EVALUATED. DATA IS LISTED FOR INDIVIDUAL COMPONENTS. ETHANOL:
ORAL-RAT LD50: 7060 MG/KG; IHL-RAT LC50 : 20000 PPM/10H. MEYHANOL:
ORL-RAT LD50: 5628 MG/KG; IHN-RAT LC50: 64000 PPM/4H.
===================== Ecological Information =====================
Ecological:EPA WASTE NUMBER: ETHANOL (D001); METHANOL (U154).
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. ALWAYS CONTACT A PERMITTED
WASTE DISPOSER (TSD) TO ASSURE COMPLIANCE.
=================== MSDS Transport Information ===================
Transport Information:DESCRIPTION: ETHANOL SOLUTIONS, 3, UN1170, II.
===================== Regulatory Information =====================
SARA Title III Information:HAZARD CATEGORY FOR SARA SECTION 311/312
REPORTING: ACUTE, FIRE. SARA SEC. 313 CHEMICALS NAME LIST: YES.
Federal Regulatory Information:CERCLA SEC. 103 RQ LBS.: 5000
(METHANOL). RCRA SEC. 261.33: YES (METHANOL). EPA TSCA STATUS: ON
TSCA INVENTORY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EOSIN SOLUTION II, 4000
CAGE:JO386
CAGE:JO386
CAGE:55930
============= Composition/Information on Ingredients =============
Ingred Name:EOSIN Y
CAS:548-26-5
RTECS #:LM5850000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF SWALLOWED. MATERIAL
IS IRRITATING TO MUCOUS MEMBRANES AND UPPER RESPIRATORY TRACT.
CAUSES EYE AND SKIN IRRITATION. ONLY SELECTED REGISTRY OF TOXIC
EFFECTS OF CHEMICAL SUBSTANCES (RTE CS) DATA IS PRESENTED HERE. SEE
ACTUAL ENTRY IN RTECS FOR COMPLETE INFORMATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . EYES/SKIN CONT: IMMED FLUSH EYES
OR SKIN WITH COPIOUS AMOUNTS OF WATER FOR AT LST 15 MINS WHILE
REMOVING CONTAMINATED CLOTHING & SHOES. INHAL: REMOVE TO FRESH AIR.
I F NOT BREATHING, GIVE ARTIFICIAL RESPIRATION; PREFERABLY
MOUTH-TO-MOUTH. IF BREATHING IS DIFFICULT, GIVE OXYGEN. CALL
PHYSICIAN. WASH CONTAMINATED CLOTHING BEFORE RE-USE.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL,
ALCOHOL-TYPE OR UNIVERSAL TYPE FOAMS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
DISPOSABLE TOWELS. SMALL SPILLS SHOULD BE FLUSHED WITH LARGE
QUANTITIES OF WATER. LARGE SPILLS SHOULD BE COLLECTED FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN OR
CLOTHING. STORE COOL, DRY AREA. STORE IN TIGHTLY CLOSED CONTAINER.
DO NOT INGEST.
Other Precautions:PROTECT UNITS AGAINST PHYSICAL DAMAGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:GENERAL (MECHANICAL) ROOM VENTILATION SHOULD BE SUITABLE.
SPECIAL LOCAL, VENTILATION SHOULD BE USED AT POINTS (SUPDAT)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . LAB
COAT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VENT: WHERE VAPORS ARE EXPECTED TO BE VENTED TO THE WORKPLACE AIR.
================== Physical/Chemical Properties ==================
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
HYDROGEN BROMIDE GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH WITH WATER, CONTROLLED BURNING. NOTE:
DISPOSAL OF HAZARDOUS MATERIAL MAY BE SUBJECT TO FEDERAL, STATE, OR
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HIDE ALL SEMI-GLOSS WHITE, 050609
CAGE:3Y107
CAGE:09MD8
CAGE:3Y107
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA). VP:0.1 @ 68F.
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:50 PPM, VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 2.03 LB/GL (244 GR/LT).
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:RESIDUAL VAPORS MAY
BE IRRITATING TO EYES, SKIN, MUCOUS MEMBRANES, RESPIRATORY TRACT
AND MAY PRODUCE HEADACHE AND NAUSEA IN POORLY VENTILATED AREAS.
SKIN CONTACT/ABSORPTION: PROLONGEDOR REPEATED CONTACT WITH PAINT
MAY CAUSE IRRITATION. EYE CONTACT:DIRECT CONTACT WITH PAINT MAY
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:RESULT IN IRRITATION. INGESTION:DO NOT
INGEST. CHRONIC:SKIN CONTACT:PROLONGED OR REPEATED CONTACT WITH
PAINT MAY CAUSE IRRITATION.
Medical Cond Aggravated by Exposure:ALLERGY OR SKIN SENSITIZATION.
======================= First Aid Measures =======================
First Aid:SKIN:WASH THOROUGHLY W/SOAP & WARM WATER. EYES:IMMEDIATELY
FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES & CONSULT MD.
INGEST:GIVE TWO GLASSES OF WATER & CALL MD. INHAL:MOVE SUBJECT TO
FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:200F,93C
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROT EQUIP .
WATER MAY BE USED TO COOL CLOSED CNTNRS TO PVNT PRESS BUILD-UP &
POSSIBLE EXPLO WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER LIQUID W/ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID
PROLONGED CONTACT W/SKIN.
Other Precautions:EMPTY CONTAINER WARNING:I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CONFINED AREAS & WHEN SPRAYING, USE NIOSH
APPROVED RESPIRATORY DEVICES.
Ventilation:PROPER VENTILATION.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . NONE NEEDED UNLESS SPECIAL EQUIPMENT
DESIRED.
Work Hygienic Practices:WASH HANDS AFTER USE, BEFORE EATING OR USING
WASHROOM.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:1.2 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SOLUBLE
Appearance and Odor:VISCOUS LIQUID; MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXTREME TEMPERATURES IN CLOSED CONTAINERS.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W ALL LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:200 MV SOLUTION
CAGE:52998
CAGE:52998
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >97%
Ingred Name:POTASSIUM CHLORIDE
CAS:7447-40-7
RTECS #:TS8050000
Fraction by Wt: <1%
Ingred Name:POTASSIUM FERRICYANIDE
CAS:13746-66-2
RTECS #:LJ8225000
Fraction by Wt: <1%
Ingred Name:POTASSIUM FERROCYANIDE
CAS:13746-66-2
RTECS #:LJ8225000
Fraction by Wt: <1%
Other REC Limits:5 MG/CUM
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: GASTROINTESTINAL UPSET,
NAUSEA, DIARRHEA, & CRAMPING. SKIN/EYES: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION: GASTROINTESTINAL UPSET, NAUSEA,
DIARRHEA, & CRAMPING. SKIN/EYES: IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN/EYES: FLUSH W/WATER. INGESTION: OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:ANY MEANS SUITABLE FOR OTHER MATERIALS INVOLVED.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION, MAY EMIT
TOXIC FUMES OF CYANIDES.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP ON ABSORBENT & FLUSH AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL PLACE. KEEP IN TIGHTLY
CLOSED CONTAINER.
Other Precautions:MAY STAIN CLOTHING.
============= Exposure Controls/Personal Protection =============
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:YELLOW SOLUTION ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, SODIUM NITRATE, AMMONIA, CHROMIUM TRIOXIDE, CHROMIC ANHYDRIDE, &
CUPRIC NITRATE
Stability Condition to Avoid:HEATING TO DECOMPOSITION
Hazardous Decomposition Products:TOXIC FUMES WHEN HEATED TO
DECOMPOSITION OR ON CONTACT W/ACIDS
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH TO SEWER W/EXCESS WATER IN ACCORDANCE
W/FEDERAL, STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SKL-HT SPOTCHECK PENETRANT
Preparer's Name:BRUCE C. GRAHAM (CHEMIST)
CAGE:37676
CAGE:37676
============= Composition/Information on Ingredients =============
Ingred Name:DETERGENTS (KIND NOT SPECIFIED)
Ingred Name:SOLVENTS (TYPE NOT SPECIFIED)
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATES EYES
Effects of Overexposure:INHALATION:SPRAY MIST MAY BE IRRITATING TO
BREATHING PASSAGES; EYES:LIQUID CONTACT MAY CAUSE IRRITATION;
SKIN:SOLVENT IN THE PRODUCT MAY IRRITATE SKIN; INGESTION:NOT NOTED
BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NOT STATED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR.IF BREATHING IS DIFFICULT,GIVE
OXYGEN; SKIN:REMOVE CONTAMINATED CLOTHES.WASH OFF WITH FLOWING
WATER.USE SOOTHING LOTION.IF IRRITATION PERSISTS,GET MEDICAL ATTN;
EYES:IMM EDIATELY RINSE/FLUSH WITH COPIOUS AMOUNT OF RUNNING
WATER,AND GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>300F/149C
Extinguishing Media:CARBON DIOXIDE,FOAM,WATER
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:WHEN INVOLVE IN COMBUSTION,MAY EMIT TOXIC
GASES AT OR ABOVE DECOMPOSITION TEMPERATURE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.SM QTY:WIPE UP OR MOP
UP BUT DO NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUMS; LG
QTY:WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA FAR AHEAD.ABSORB
LIQUID WITH COMMERCIAL ABSORBEN T.TRANSFER WASTE MATL IN SALVAGE
TANKS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA.AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS.KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS.DO NOT SMOKE WHILE USING.DO NOT
HEAT ABOVE 130F(54C).AVOID FREQUENT OR PROLONGED SKIN CONTACT.DO
NOT SPRAY OR USE NEAR OPEN FLAMES,WELDING ARCS OR HOT SURFACES OVER
350F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR FULL MASK WITH SEPARATE AIR SUPPLY IN
CONFINED AREA.
Ventilation:ADEQUATE VENTILATION
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE.
Supplemental Safety and Health
SKL-HT PENETRANT IS FOR USE AT HIGH TEMPERATURES(RANGE 150-350F).ONE
PART FAULT FINDER;NOT AVAILABLE IN AEROSOL CANS; QPL-25135-15
SPECIFIED SKL-HT AS TYPE II,METHOD C,PENETRANT UNDER
MIL-I-25135D;THE QPL ALSO SPECIFIED SKL-HF/S,SKL-LT,SKL-LO,&
SKL-WP UNDER TYPE II,METHOD C,SAME SPEC.SEE OTHER PNI FOR THESE
ITEMS.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.0
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OIL,RED LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT KNOWN
Stability Condition to Avoid:HEAT,HIGH TEMPERATURES.
Hazardous Decomposition Products:EMITS OXIDES OF CARBON AND NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF AS EPA HAZARDOUS WASTE
D001 (IGNITABLE WASTE),IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL,STATE,LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:R-22
Preparer's Name:DGSC-VBA/HMIS
CAGE:02LX8
CAGE:02LX8
============= Composition/Information on Ingredients =============
Ingred Name:CHLORODIFLUOROMETHANE (SARA 313) (CERCLA)
CAS:75-45-6
RTECS #:PA6390000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9495
Ozone Depleting Chemical:2
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV 1,000 PPM.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:CNS, EYE, SKIN, LUNG.
ACUTE- HARMFUL IF INHALED. MAY CAUSE HEART IRREGULARITIES,
UNCONSCIOUSNESS OR DEATH. INTENTIONAL MISUSE IS FATAL. VAPOR
REDUCES OXYGEN & IS HEAVIER THAN AIR. EYE/SK IN CONTACT WITH LIQUID
CAN CAUSE FROSTBITE. VAPORS CAN CAUSE EYE IRRITATION. INGESTION IS
UNLIKELY. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:TEMPORARY NERVOUS SYSTEM DEPRESSION WITH
ANAESTHETIC EFFECTS SUCH AS DIZZINESS, HEADACHE, CONFUSION,
INCOORDINATION, LOSS OF CONSCIOUSNESS, IRREGULAR PULSE,
PALPITATIONS, INADEQUATE CIRCULATION, FROST BILTE, IRRITATION,
BLURRED VISION, TEARING
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PREEXISTING
DISEASES OF THE CENTRAL NERVOUS OR CARDIOVASCULAR SYSTEM MAY HAVE
INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF NEEDED. EYE/SKIN:IMMEDIATELY FLUSH
WITH PLENTY OF WATER. INHALED:REMOVE TO FRESH AIR & PROVIDE
OXYGEN/CPR IF NEEDED. ORAL:INGESTION IS NOT CONSIDERED A POTENTIAL
ROUTE OF EXPO SURE. NOTE TO PHYSICIAN:CATECHOLAMINE DRUGS SHOULD BE
USED WITH SPECIAL CAUTION ONLY IN SITUATIONS OF EMERGENCY LIFE
SUPPORT.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER, CO2, FOAM OR DRY CHEMICAL. WATER SPRAY MAY
BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL & FLUSH SPILLS AWAY.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. SEE 1990 EMERGENCY RESPONSE
GUIDEBOOK, DOT P 5800.5, GUIDE NO 12.
Unusual Fire/Explosion Hazard:THIS PRODUCT CAN BE DECOMPOSED BY HIGH
TEMPERATURES (OPEN FLAMES, GLOWING METALS) FORMING HYDROGEN
FLUORIDE, HYDROGEN CHLORIDE AND TRACES OF CARBONYL HALIDES.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA, ESPECIALLY LOW PLACES WHERE
VAPORS MIGHT COLLECT. REMOVE OPEN FLAMES. USE SELF-CONTAINED
BREATHING APPARATUS FOR LARGE SPILLS OR RELEASES.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA, AWAY FROM FLAMES & INCOMPATIBLE MATERIALS. DO NOT HEAT ABOVE
125F.
Other Precautions:AVOID BREATHING VAPORS. AVOID EYE OR SKIN CONTACT.
WASH WITH SOAP AND WATER BEFORE EATING OR DRINKING. USE WITH
ADEQUATE VENTILATION. NEVER USE IN CONFINED OR CLOSED SPACES
WITHOUT PROPER PROTECTIVE E QUIPMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS OPERATED IN POSITIVE PRESSURE MODE OR SUPPLIED-AIR
RESPIRATOR WITH FULL FACEPIECE AND OPERATED IN PRESSURE-DEMAND OR
OTHER POSITIVE PRESSURE MODE IF A LARGE RELEASE OCCURS.
Ventilation:NORMAL VENTILATION IS SUFFICIENT. LOCAL EXHAUST WHEN LARGE
AMOUNTS ARE RELEASED, MECHANICAL VENTILATION IN LOW PLACES
Other Protective Equipment:EYEBATH, SAFETY SHOWER, PROTECTIVE CLOTHING
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING.
Supplemental Safety and Health
THIS MSDS WAS PREPARED BY THE PROFESSIONALS OF DGSC-VBA/HMIS WITHOUT
ANY WARRANTY. IT IS THE USER'S RESPONSIBILITY TO GATHER INFORMATION
AND USE THE MATERIAL PROPERLY TO PROTECT EMPLOYEES AND ENVIRONM
ENT. OTHER TRADE NAME: REFRIGERANT 12.
================== Physical/Chemical Properties ==================
HCC:G3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:-41F,-41C
Melt/Freeze Pt:M.P/F.P Text:-256F,-160C
Decomp Temp:Decomp Text:1170F,632C
Vapor Density:3.03 @ 77F
Spec Gravity:1.194 (LIQUID)
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:>1 (CCL4 = 1)
Solubility in Water:0.30 BY WT @ 25C/77F
Appearance and Odor:CLEAR, COLORLESS LIQUEFIED GAS - SLIGHT ETHEREAL
ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI OR ALKALINE EARTH METALS, POWDERED ALUMINUM, ZINC, BERYLLIUM,
ETC.
Stability Condition to Avoid:FLAME, GLOWING METAL SURFACES
Hazardous Decomposition Products:MAY FORM HYDROGEN FLUORIDE, HYDROGEN
CHLORIDE AND TRACES OF CARBONYL HALIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECLAIM BY DISTILLATION. CONSULT LOCAL, STATE
AND FEDERAL AUTHORITIES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:527 PERMAGLOSS PLUS FLOOR FINISH
CAGE:02176
CAGE:02146
CAGE:02176
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SLIGHT IRRITANT. INGESTION:
EXTREMELY LARGE DOSES COULD CAUSE INJURY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DRYING
Medical Cond Aggravated by Exposure:EXISTING CONDITIONS OF DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/COPIOUS AMOUNTS OF WATER. CONTINUE FOR 15 MINS.
SKIN: WASH OFF W/WATER & THEN WASH AREA W/SOAP & WATER. INHALATION:
REMOVE TO FRESH AIR. INGESTION: INDUCE VOMITING BY GIVING
IPECAC/STICK ING A FINGER TO THE BACK OF THE THROAT.NEVER GIVE
ANYTHING BY MOUTH IF UNCONSCIOUS. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:FOAM, CO2, WATER FOG
Fire Fighting Procedures:RELEASE OF THE MATERIAL MAY RESULT IN SLIPPERY
CONDITIONS.
Unusual Fire/Explosion Hazard:COOL FIRE EXPOSED CONTAINERS W/A WATER
SPRAY TO PREVENT BURSTING OF CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AREA TO CONTAIN MATERIAL. AREA MAY BECOME
SLIPPERY. ABSORB PRODUCT ONTO POROUS MATERIAL SUCH AS SAND,
DIATOMACEOUS EARTH/COMMERCIAL ABSORBENT MATERIAL. SHOVEL UP INTO
DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE IN SUBFREEZING
TEMPERATURES/EXTREME CONDITIONS OF HEAT.
Other Precautions:DON'T MIX W/OTHER CHEMICALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED DURING THE NORMAL USE OF THE
PRODUCT.
Ventilation:NORMAL GOOD VENTILATION IS SUFFICIENT. IN CONFINED AEAS:
MECHANICAL DEVICES ARE RECOMMENDED.
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:200F
Vapor Pres:27
Vapor Density:>1
Spec Gravity:1.033
pH:8-9
Evaporation Rate & Reference:SLOWER THAN WATER
Appearance and Odor:MILKY WHITE EMULSION W/MILD ODOR
Percent Volatiles by Volume:80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FREEZING, EXTREME HEAT
Hazardous Decomposition Products:CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE/LANDFILL/DISPOSE OF IN ACCORDANCE
W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LAURYL TRYTOSE BROTH WITH BROMCRESOL PURPLE, 26002
CAGE:4T252
CAGE:4T252
============= Composition/Information on Ingredients =============
Ingred Name:PROTEIN HYDROLYZATES; (TRYPTOSE)
CAS:9015-54-7
RTECS #:UK9595700
Fraction by Wt: <15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LACTOSE
CAS:63-42-3
RTECS #:OD9625000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OTHER COMPONENTS(EACH)
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRACTICALLY NON-TOXIC. SPECIAL NOTE:
IN A LAB TEST, SINGLE SUBCUTANEOUS INJECTION OF SODIUM CHLORIDE
INTO PREGNANT MICE AT LEVEL OF 2500 MG/KG CAUSED FETAL DEAFNESS &
MALFORMATIONS. IN LAB TEST, MICE GIVEN A 2% SOLUTION IN PLACE OF
DRINKING WATER DURING PREGNANCY PRODUCED HYPERTENSIVE ADULT
OFFSPRING.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE REPORTED.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES. SKIN:
FLUSH W/PLENTY OF WATER. INGEST: GIVE LARGE QUANTITIES OF WATER.
CALL MD IMMED. INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING(GIVE
O*2/ARTF RESP).
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE WITH WATER. POUR DOWN THE DRAIN WITH
EXCESS WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TIGHTLY CLOSED IN A COOL, DRY
PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN.
Ventilation:ADEQUATE VENTILATION.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR DARK PURPLE LIQUID SOLUTION.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:BACTERIAL CONTAMINATION, HIGH
TEMPERATURES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:631 SOLVENT
CAGE:DO849
CAGE:29700
CAGE:DO849
============= Composition/Information on Ingredients =============
Ingred Name:C*7-C*10 SATURATED HYDROCARBON
Fraction by Wt: 83%
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 0.4%
Other REC Limits:375 MG/CUM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0.8%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 0.2%
Other REC Limits:100 PPM
OSHA PEL:435 MG/CUM
ACGIH TLV:434 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:C8 + AROMATICS
Fraction by Wt: 14%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): >5 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HIGH VAPOR CONCENTRATIONS ARE
ANESTHETIC & IRRITATING TO EYES, RESPIRATORY TRACT & SKIN. MAY LEAD
TO DERMATITIS. MAY HAVE OTHER CENTRAL NERVOUS SYSTEM EFFECTS
INCLUDING DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:HEADACHES, DIZZINESS, DEATH. DEFATTING.
EYES/RESPIRATORY TRACT/SKIN: IRRITATION.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE EXISTING DERMATITIS
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
PRODUCT IS READILY REMOVED FROM SKIN BY WATERLESS HAND CLEANERS.
INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS IRREGULAR OR HAS
STOPPED, START RESUSCITATION, ADMINISTER OXYGEN.INGESTION: DON'T
INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:38C (100F)
Lower Limits:0.9%
Upper Limits:7%
Extinguishing Media:FOAM, WATER SPRAY (FOG), DRY CHEMICAL, CO2, &
VAPORIZING LIQUID TYPE EXTINGUISHING AGENTS.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, BUT SHOULD BE USED
TO KEEP FIRE-EXPOSED CONTAINERS COOL. USE WATER SPRAY TO DISPERSE
VAPORS. WEAR SUPPLIED BREATHING EQUIPMENT.
Unusual Fire/Explosion Hazard:LIQUID OR VAPOR MAY SETTLE IN LOW AREAS
OR TRAVEL SOME DISTANCE ALONG GROUND OR SURFACE TO IGNITION SOURCES
WHERE THEY MAY IGNITE OR EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF IGNITION SOURCES. KEEP PEOPLE AWAY.
RECOVER FREE PRODUCT. ADD SAND, EARTH OR OTHER SUITABLE ABSORBENT.
MINIMIZE BREATHING VAPORS/SKIN CONTACT. VENTILATE; OPEN ALL WINDOW
& DOORS. KEEP OUT OF SEWERS & WATERCOURSES BY DIKING/IMPOUNDING.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS & STORAGE CONTAINERS
CLOSED WHEN NOT IN USE. LIQUID IS VOLATILE & GIVES OFF INVISIBLE
VAPORS.
Other Precautions:TO PREVENT FIRE/EXPLOSION RISK FROM STATIC
ACCUMULATION & DISCHARGE, EFFECTIVELY GROUND PRODUCT TRANSFER
SYSTEM IN ACCORDANCE W/NFPA STANDARD FOR PETROLEUM PRODUCTS. NO
SMOKING OR OPEN LIGHTS IN AREA OF USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SUPPLIED-AIR RESPIRATORY PROTECTION IN
CONFINED OR ENCLOSED SPACES
Ventilation:SUFFICIENT TO PREVENT EXCEEDING RECOMMENDED EXPOSURE LIMIT.
USE EXPLOSION-PROOF EQUIPMENT.
Other Protective Equipment:CHEMICAL-RESISTANT APRON OR OTHER IMPERVIOUS
CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. NO SMOKING IN AREA OF USE.
Supplemental Safety and Health
VISCOSITY: 0.83 CP @25C.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:308-348F
Melt/Freeze Pt:M.P/F.P Text:0F
Vapor Pres:<10
Vapor Density: 4.8
Spec Gravity:0.78
pH: 7
Evaporation Rate & Reference:(N-BU AC = 1): 0.2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR WATER-WHITE LIQUID W/MINERAL SPIRITS ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS SUCH AS LIQUID CHLORINE, CONCENTRATED OXYGEN, SODIUM
HYPOCHLORITE OR CALCIUM HYPOCHLORITE
Stability Condition to Avoid:HEAT, SPARKS, PILOT LIGHTS, STATIC
ELECTRICITY, OPEN FLAMES, OPEN LIGHTS & OTHER IGNITION SOURCES
Hazardous Decomposition Products:FUMES, SMOKE, CO, ALDEHYDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. UN 1255. COMBUSTIBLE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VF SERIES FLAT VINYL SCREEN INK, VF112
CAGE:FO883
CAGE:FO883
CAGE:76708
============= Composition/Information on Ingredients =============
Fraction by Wt: 5-50%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:SOLVENT NAPHTHA; (PETROLEUM DISTILLATE; AROMATIC
HYDROCARBON) VP: <3 @ 25C
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: 15-40%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:N/K
Ingred Name:RESIN; (MIXTURE) VP: <1 @ 20C
Fraction by Wt: 10-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:2-PENTANONE, 4-HYDROXY-4-METHYL-; (DIACETONE ALCOHOL) VP:
1.0 @ 20C
CAS:123-42-2
RTECS #:SA9100000
Fraction by Wt: 5-15%
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
Ingred Name:CYCLOHEXANONE (CERCLA) VP: 2.0 @ 20C
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 5-10%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2(3H)-FURANONE, DIHYDRO-; (GAMMA-BUTYROLACTONE) VP: 1.5 @
20C
CAS:96-48-0
RTECS #:LU3500000
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 0-6%
OSHA PEL:C 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (PETROLEUM
DISTILLATE; AROMATIC HYDROCARBON) VP: 3.0 @ 20C
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 0-5%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:N/K
Ingred Name:NAPHTHALENE; (PETROLEUM DISTILLATE; NAPHTHALENE) (SARA 313)
(CERCLA) VP: <1 @ 2OC
CAS:91-20-3
RTECS #:QJ0525000
Fraction by Wt: <5%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: <5%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.05 MG/M3 RDUST
Ingred Name:BENZENE, 1,2,4-TRIMETHYL-; (1,2,4-TRIMETHYLBENZENE) (SARA
313) VP: <1 @ 20C
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: <2%
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:SUP DAT: NONCANCEROUS LUNG DISEASE. DIACETONE ALCOHOL HAS
BEEN FOUND TO CAUSE KIDNEY & LIVER INJURY & BLOOD (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: DISORDERS IN LAB ANIMALS.
RTECS #:9999999ZZ
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: EYE CONT W/LIQ, ITS
VAPS/MISTS MAY CAUSE BURNING, TEARING, REDNESS & EYE DMG. RPTD &
PRLNG SKIN CONT MAY CAUSE SLIGHT IRRIT/MILD DERM CHARACTERIZED BY
DRYNESS, CHAPPING & REDNESS. THIS MATL MAY BE ABSORBED THRU SKIN.
RPTD & PRLNG OVEREXP BY INHAL MAY CAUSE HDCH, NAUS, DIZZ, RESP
TRACT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-CRISTOBALITE: IARC
MONO, SUPP, VOL 7, PG 341, 1987: GROUP 2A. NTP 7TH ANNUAL RPT ON
(SUP DAT)
Effects of Overexposure:HLTH HAZ: IRRIT & INTOXICATION. INGEST MAY
CAUSE GI TRACT IRRIT & SIGNS OF NERV SYS DEPRESS. INGEST MAY CAUSE
VOMIT. ASPIR OF MATL INTO LUNGS MAY CAUSE CHEM PNEUMIT WHICH CAN BE
FATAL. RPTS HAVE ASSOC RPTD & PRLNG OCCUP OVEREXP TO SOLVS W/PERM
BRAIN & NERV SYS DMG. INTENTIONAL MISUSE BY DELIBERATELY CONC &
(SUP DAT)
Medical Cond Aggravated by Exposure:PERS W/PREEXISTING SKIN/LUNG
DISORDERS MAY BE MORE SUSCEPTIBLE TO EFTS OF THIS MATL. RPTD &
PRLNG OVEREXP &/INDIVIDUAL SENSITIVITY MAY INCR POTENTIAL FOR &
DEGREE OF ADVERSE HEALTH EFFECTS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER, CONTACT MD IF IRRITATION
PERSISTS. EYES: FLUSH WELL WITH RUNNING WATER FOR A MINIMUM OF 15
MINUTES, CONTACT MD IF IRRITATION PERSISTS. INHALATION: REMOVE TO
FRESH AIR.RESTORE BREATHING, CONTACT MD. INGESTION: CONTACT MD OR
POISON CONTROL CENTER IMMEDIATELY. THE POTENTIAL HLTH EFTS OF THIS
PROD ARE BASED ON HAZARDS OF ITS COMPONENTS.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>125F,>52C
Lower Limits:1.0%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE INEFFECTIVE BUT MAY BE USED TO COOL
CONTAINERS.
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT,
SPARKS, AND OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED
TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. AVOID BREATHING VAPORS. CONTAIN RELEASE AND REMOVE WITH INERT
ABSORBENT. AVOID CONTACT. USE NON-SPARKING TOOLS TO PLACE MATERIAL
IN APPROVED CONTAINER F OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS IN COOL,
DRY, WELL VENTILATED AREA AWAY FROM SOURCES OF IGNITION. KEEP
CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:AVOID PROLONGED OR REPEATED OVEREXPOSURE TO THIS
PRODUCT. EMPTY CONTAINERS SHOULD BE DISPOSED OF IN AN
ENVIRONMENTALLY SAFE MANNER IN ACCORDANCE WITH APPLICABLE
REGULATIONS. THE USE OF CONTACT LENSES IS NOT RECOMMENDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VAPOR CONCENTRATION EXCEEDS TLV, USE NIOSH
APPROVED RESPIRATOR WITH ORGANIC CHEMICAL CARTRIDGE. CONTACT A
REPUTABLE SAFETY SUPPLY COMPANY FOR THE APPROPRIATE RESPIRATOR.
Ventilation:USE APPLICABLE ENGINEERING CONTROL, WORK PRACTICES, &
PERSONAL PROTECTIVE EQUIPMENT TO KEEP VAPOR CONC BELOW TLV.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . SOLVENT-RESISTANT APRON.
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE EATING, SMKNG/USING
TOILET FACILITIES. REMOVE CONTAM CLTHG TO PREVENT PRLNG SKIN
CONTACT.
Supplemental Safety and Health
EXPLAN OF CARCIN: CARCINS, 1994: ANTIC TO BE CARCIN. EFTS OF OVEREXP:
INHALING CONTENTS MAY BE HARMFUL/FATAL. CRYSTALLINE SILICA IS
CLASSIFIED AS PROBABLE CARCIN BY NTP & IARC (GROUP 2A). OVEREXP
SHOU LD NOT OCCUR DURING NORM USE. EXCESS EXPOS TO CRYSTALLINE
SILICA IS ALSO A KNOWN CAUSE OF SILICOSIS, A (ING 13)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.4
VOC Pounds/Gallon:553
VOC Grams/Liter:4.6
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:61
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALKALIS, AND REACTIVE CHEMICALS.
Stability Condition to Avoid:HEAT, SPARKS, AND OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER NOXIOUS GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:210 SOLDERING FLUX 1220
Preparer's Name:TED VAN DER MOLEN
CAGE:84311
CAGE:84311
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:DIPROPYLENE GLYCOL METHYL ETHER *92-2*
CAS:20324-32-7
Other REC Limits:600 MG/CUM
Ingred Name:ROSIN ACID *92-2*
CAS:8050-09-7
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; PETROLEUM DISTILLATE,
HYDROTREATED
CAS:64742-47-8
RTECS #:OA5504000
Other REC Limits:900 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF NOSE,
THROAT, HEADACHE, DIZZINESS, NARCOTIC & IMPAIRED PULMONARY
FUNCTION. INGESTION: MAY GENERATE HEAT & LOWER BLOOD PRESSURE.
SKIN: REMOVES OIL MAKING SKIN DRY & CRACKED. E YES: CORNEAL BURNS,
EYE DAMAGE, IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: IRRITATION OF NOSE, THROAT,
HEADACHE, DIZZINESS, NARCOTIC & IMPAIRED PULMONARY FUNCTION.
INGESTION: MAY GENERATE HEAT & LOWER BLOOD PRESSURE. SKIN: REMOVES
OIL MAKING SKIN DRY & CRACKED. E YES: CORNEAL BURNS, EYE DAMAGE,
IRRITATION.
Medical Cond Aggravated by Exposure:SKIN, LIVER & KIDNEY DISORDERS,
RESPIRATORY DISEASE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. MALAISE SHOULD BE TRANSIENT.
EYES: WASH W/PLENTY OF WATER & USE ISOTOPIC SOLUTION. SKIN: WASH
W/SOAP & WATER & APPLY HAND CREAM. INGESTION: INDUCE VOMITING BY
TOUCHING BACK OF THROAT W/FINGER. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:52F
Lower Limits:2%
Upper Limits:12%
Extinguishing Media:ALCOHOL FOAM, DRY CHEMICAL, CO2
Fire Fighting Procedures:SELF-SUSTAINED BREATHING APPARTUS. KEEP
NON-BURNING CONTAINERS COOL BY DOUSING W/WATER.
Unusual Fire/Explosion Hazard:FIRE DANGER WHEN EXPOSED TO HEAT OR
FLAME. EXPLODE MODERATE WHEN EXPOSED TO HEAT OR FLAME.
AUTO-IGNITION TEMP: 750F.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL-ADD PLENTY OF WATER AT ONE TIME.
LARGE-EXTINGUISH ALL FIRE, OPEN WINDOWS, EVACUATE PEOPLE, ADD
ABSORBENT, LET EVAPORATE. PUT ABSORBENT IN CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN COOL AREA & AWAY FROM SOURCE
OF HEAT. IN HOT WEATHER, OPEN CONTAINER SLOWLY TO LET VAPORS
EXCAPE.
Other Precautions:BARREL & CONTAINERS SHOULD BE GROUNDED TO PREVENT
SPARKS. DON'T SMOKE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED AT ROOM TEMP ONLY NORMAL
VENTILATION. DURING A SOLDERING PROCESS, A RESPIRATOR APPROVED BY
NIOSH/MINE SAFETY & HEALTH ADMIN IF GOOD VENTILATION OR EXHAUST IS
NOT AVAILABLE.
Ventilation:RECOMMENDED
Other Protective Equipment:EYE BATH, SHOWER, PROTECTIVE CLOTHING
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING, DRINKING OR SMOKING. SHOWER IF SPILLED ON
SKIN.
Supplemental Safety and Health
DON'T ALLOW PREGNANT WOMEN IN A SOLDERING AREA.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:181F
Melt/Freeze Pt:M.P/F.P Text:-127F
Vapor Pres:33
Vapor Density:2.7
Spec Gravity:0.885
Evaporation Rate & Reference:(BU AC = 1): 1.7
Solubility in Water:65%
Appearance and Odor:AMBER LIQUID W/ETHEREAL ODOR.
Percent Volatiles by Volume:70%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL
Stability Condition to Avoid:HEAT, FLAME
Hazardous Decomposition Products:CO2, CO, VARIOUS HYDROCARBONS & SOOTY
MATTER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. FLAMMABLE.
| 1 | gloves_mandatory |
=======================================================
Product ID: SYSTEM-1 FRESH AND CLEAN LAUNDRY DETERGENT
Cage: IO718
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 0TMN6
Cage: IO718
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: IRRITANT TO SKIN & EYES. PROLONGED EYE CONT MAY
CAUSE PERM DAM. CHRONIC: NONE KNOWN. INHAL: MAY CAUSE IRRIT TO NOSE, THROAT,
& MUC MEMB, TISSUE DAM, & PULM IRRIT. INGEST: MAY CAUSE NAUS, VOMIT
& TISSUE DAM TO MOUTH, ESOPHAGUS, STOMACH, AND TO OTHER TISSUES WITH
WHICH CONTACT IS MADE. SKIN: CONT (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: MAY CAUSE MILD TO SEVERE
IRRITATION, DEPENDING ON DEGREE OF EXPOS. EYES: CONT MAY CAUSE TEARING,
SEVERE IRRITATION, BURNING, VISION LOSS, AND BLINDNESS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INGEST: DO NOT INDUCE VOMIT. IF CONSCIOUS & CAN SWALLOW,
ADMINISTER MILK/WATER. SKIN: REMOVE CONTAMD CLOTHES, FLOOD W/WATER FOR 15
MIN. EYE: FLUSH W/LUKEWARM (NOT HOT) WATER POURED FROM A LG GLASS 2-3 INCHES
FROM EYES. REMOVE CONT. HAVE PATIENT BLINK AS MUCH AS POSS WHILE FLOODING
EYES. CONTINUE FOR @ LST 15 MIN. INHAL: MOVE TO FRESH AIR. GIVE ARTF RESP IF
PATIENT IS NOT BRTHG. ADMINISTER (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: WEAR PROPER PROT EQUIP INCL RUBB BOOTS. STOP LEAK IF
YOU CAN DO SO W/OUT RISK. DIKE/DAM LG SPILLS. VENT AREA IF NEEDED. SOAK UP
W/SAND/OTHER NON-COMBUST INERT ABSORB MATLS. FLUSH AREA W/WATER & FOLLOW
W/NORM CLEAN-UP PROC. KEEP COMBUST AWAY! (SUPDAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: COMPLY W/ALL FED, ST, & LOC REGS. CONSULT ST &
LOC AUTH FOR RESTRICTIONS ON DISP OF CHEM WASTE. IF APPRVD, MAY BE DILUTED
& DRAINED TO A MUNICAL SEWER/WASTE TRTMT PLANT. RINSE EMPTY CONTR THORO
W/WATE R BEFORE DISCARDING.
Handling And Storage Precautions: FOLLOW ALL LBL DIREC. INSTRUCT PERS ABOUT
PROPER USE, HAZS, PREC, & FIRST-AID MEASURES. AVOID INHAL, INGEST &
CONT W/SKIN & EYES.
Other Precautions: RECOMM STORAGE TEMP BELOW 100F. KEEP OUT OF CHILDREN'S
REACH.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: FOR FIRES IN AREA, USE APPROPRIATE MEDIA. FOR EXAMPLE:
WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE OR ALCOHOL FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N) EVACUATE AREA OF UNPROTECTED AND UNNECESSARY PERSONNEL.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED WITH NORMAL USE. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: GEN MECH: SATISFACTORY. MAINTAIN ADEQ VENT. KEEP LEVELS BELOW
RECOMM TLV. LOC EXHST: NOT ORDINARILY NEEDED. (SUPDAT)
Other Protective Equipment: EYE-WASH STATION MTG ANSI DSGN STNDS (FP N). WEAR
FULL-COVER PROTECTIVE CLOTHING TO PREVENT REPEATED OR PRLNGED CONTACT.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: PH: 10.2(CONC). FIRST AID PROC: FIRST AID TRTMT
AS STATED ABOVE, THEN CALL 1-800-228-5635 EXT 075/CONT PHYS FOR FURTHER MED
INSTRUCTIONS. SPILL PROC: BE CAREFUL AS SPILLS ARE SLIPPERY. VENT: AVOID INH
W/FULL LGTH FCSHLD (FP N).
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.022(H*2O=1)
PH: SUPDAT
Solubility in Water: COMPLETE
Appearance and Odor: BLUE, SLIGHTLY VISCOUS CLEAR SOLUTION, LEMON SCENT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID MIXING W/ANY OTHER CLEANING PROD. MIX ONLY
W/WATER. DO NOT STORE @ HIGH TEMPS. RECOM STOR TEMP
Materials To Avoid: ACIDIC MATERIALS AND OXIDIZING AGENTS.
Hazardous Decomposition Products: MIXING WITH INCOMPATIBLE MATERIALS MAY
PRODUCE CARBON DIOXIDE, HYDROGEN, AND OTHER TOXIC AND IRRITATING FUMES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: SYSTEM-1 FRESH AND CLEAN LAUNDRY DETERGENT
Cage: IO718
Assigned IND: Y
Company Name: U.S. CHEMICAL
Street: 316 HART ST
Zipcode: 53094
Label Required IND: Y
Date Of Label Review: 01/31/1994
Status Code: C
Label Date: 01/31/1994
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: STORE BELOW 100F. ACUTE: INHALATION OF MISTS MAY CAUSE
IRRITATION TO NOSE, THROAT AND MUCOUS MEMBRANES, TISSUE DAMAGE AND PULMONARY
IRRITATION. INGESTION MAY CAUSE NAUSEA, VOMITING AND TISSUE DAMAGE T O MOUTH,
ESOPHAGUS, STOMACH AND TO OTHER TISSUES W/CONTACT IS MADE. SKIN CONTACT MAY
CAUSE MILD TO SEVERE IRRITATION. EYE CONTACT MAY CAUSE TEARING, SEVERE
IRRITATION, BURNING, VISION LOSS AND BLINDNE SS. CHRONIC: NONE LISTED BY
MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GEL-LUBE, 92660
Preparer's Name:MLH
CAGE:18399
CAGE:18399
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE; (N-HEXANE) (CERCLA) LD50(ORAL,RAT):28710 MG/KG
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 40-50%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 20-30%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED HEAVY
PARAFFINIC, (SEVERE SOLVENT-REFINING AND/OR (ING 4)
CAS:64742-65-0
RTECS #:PY8038501
Fraction by Wt: 10-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 3:HYDROTREATMENT); (PETROL OIL) LD50 (ORAL,RAT):3000
MG/KG
RTECS #:9999999ZZ
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT DEWAXED HEAVY
NAPHTHENIC, (SEVERE SOLVENT-REFINING AND/OR (ING 6)
CAS:64742-63-8
RTECS #:PY8038001
Fraction by Wt: 1-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 5:HYDROTREATMENT); (PETROL OIL) LD50(ORAL,RAT):13000
MG/KG
RTECS #:9999999ZZ
Ingred Name:PETROLATUM LD50(ORAL,RAT):13000 MG/KG
CAS:8009-03-8
RTECS #:SE6780000
Fraction by Wt: 1-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND:4.22 LBS/GAL, 505 GRAMS/LITER;
VOC/GRAM SOLID:NOT APPLICABLE; %VOC:68
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAUSES EYE AND SKIN IRRITATION.
ABSORPTION THROUGH SKIN MAY BE HARMFUL. EXCESS INHALATION MAY CAUSE
DIZZINESS, GIDDINESS AND NAUSEA. PROLONGED AND REPEATED INHALATION
MAY BE HARMFUL TO RESPIRATORY SYS TEM, LIVER AND KIDNEYS. REPEATED
AND PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT DAMAGE
TO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:CNS. VAPORS MAY CAUSE THE BEGINNING
OF PERIPHERAL NEUROPATHY. INGESTION CAUSES NAUSEA, CRAMPS,
VOMITING, DIARRHEA, OR ACUTE EFFECT TO CNS. INGESTION CAUSES LOSS
OF APPETITE AND PARESTHIA OF THE EXTREMITIES. MISUSE OR DELIBERATE
INHALATION MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES AND CALL PHYSICIAN. SKIN:WASH THOROUGHLY WITH PLENTY OF
WATER AND SOAP. INHALATION:IF AFFECTED, REMOVE TO FRESH AIR,
ADMINISTER OXYG EN AND CALL PHYSICIAN. INGESTION:SEEK PHYSICIAN
IMMEDIATELY, SHOW MSDS OR LABEL. DO NOT INDUCE VOMITING. ASPIRATION
CAUSES SEVERE LUNG IRRITATION, COUGHING AND PULMONARY EDEMA.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-123F,-86C
Lower Limits:1.8%
Upper Limits:12.0%
Extinguishing Media:WATER, FOG, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EXPOSURE TO FIRE, HEAT OR PROLONGED
SUNLIGHT MAY CAUSE BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE THE
AREA. WEAR APPROVED RESPIRATORY PROTECTION. CLEAN UP WITH ABSORBENT
MATERIAL. CONTAIN AND PICK UP WASTE MATERIALS, PUT IN A SEALED
APPROVED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPKS,
FLAMES/SOURCES OF IGNIT. AVOID PRLNGD/RPTD BRTHG OF GAS, FUMES,
VAP/SPRAY MIST. AVOID CONT W/EYES & SKIN.
Other Precautions:DO NOT PUNCTURE, INCIN, BURN/STORE CNTNRS >120F
(47C). IN CASE OF ACCIDENT/ILLNESS, SEEK MD IMMED, SHOW LBL/MSDS.
KEEP OUT OF REACH OF CHILDREN. ALWAYS READ & FOLLOW DIRECTIONS ON
PROD LBL. ADDNL TECH NICAL DATA SHEETS &/OR MATL SFTY(SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION IS INADEQUATE, WEAR NIOSH/MSHA
APPROVED RESPIRATORY EQUIPMENT.
Ventilation:LOCAL:REQUIRED. MECHANICAL:RECOMMENDED. SPECIAL:KEEP AWAY
FROM HEAT AND FLAME.
Other Protective Equipment:EMERG EYE WASH AND DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THORO AFTER USING. DO NOT USE PROD WHILE
EATING, DRINKING OR USING TOBACCO PRODUCTS.
Supplemental Safety and Health
BP:-40F/-40C PROPELLANT. OTHER PRECS:DATA SHEETS (MSDS) AVAILABLE UPON
REQUEST. FOR PROFESSIONAL AND INDUSTRIAL USE ONLY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SUPP DATA
Vapor Density:4.0
Spec Gravity:0.7
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:NIL
Appearance and Odor:CLEAR LIQUID, SOLVENT ODOR.
Percent Volatiles by Volume:89
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPARKS, FLAMES OR
SOURCES OF IGNITION.
Hazardous Decomposition Products:CO*2, PYROLYSIS PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH ALL FEDERAL,
STATE AND LOCAL REGULATIONS. DO NOT PUNCTURE, INCINERATE OR BURN
CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TIN OXIDE
CAGE:41946
CAGE:41946
============= Composition/Information on Ingredients =============
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 100%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN/INGESTION: IRRITATION.
INHALATION: STANNOSIS A FORM OF PNEUMOCONIOSIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN/INGESTION: IRRITATION. INHALATION;
STANNOSES A FORM OF PNEUMOCONIOSIS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MIN. SKIN: FLUSH W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:DOES NOT BURN
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT BY SWEEPING WET OR W/THE AID OF
SWEEPING COMPOUND. RESPIRATORY PROTECTION SHOULD BE WORN.
======================Handling and Storage ======================
Handling and Storage Precautions:MINIMIZE SKIN CONTACT WHEN WORKING.
AVOID PROCEDURES THAT WOULD GENERATE EXCESS DUST. USE
POLYETHYLENE-LINED FIBERBOARD DRUMS W/PLASTIC LIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED DUST MASK
Ventilation:GENERAL
Other Protective Equipment:WORK CLOTHES
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SUBLIMES
Spec Gravity:6.9
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID, WHITE POWDER W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SUBSTANCES THAT MIGHT LEAD TO THE FORMATION OF VOLATILE HYDRIDES OR
HALIDES OF ORGANIC TIN COMPOUNDS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: CATALYST FOR 463-6-78, X-515
Kit Part: Y
Cage: 0S4B8
Box: 5695
=======================================================
Contractor Summary
=======================================================
Cage: 0S4B8
Box: 5695
=======================================================
Ingredients
=======================================================
Cas: 71-55-6
RTECS #: KJ2975000
LD50(ORAL, RAT):10300 MG/KG. VP:100.0 @ 68F MM/HG
% Wt: 88.7
OSHA PEL: 350 PPM
ACGIH TLV: 350 PPM; 450 STEL
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
Ozone Depleting Chemical: 1
------------------------------
Cas: 71-36-3
RTECS #: EO1400000
VP: 5.5 @ 68F MM/HG
% Wt: 5.1
OSHA PEL: 100 PPM
ACGIH TLV: 50 PPM, S, C
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 1760-24-3
RTECS #: KV7400000
(ORAL, RAT): 7460 MG/KG
% Wt: 1-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
% Wt: 1-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 90-72-2
RTECS #: SN3500000
(TRI(DIMETHYLAMINOMETHYL)PHENOL) LD50 (ORAL, RAT): 11800 MG/KG
% Wt: 1-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
RTECS #: 9999999VO
LBS/GAL. VOC(TOTAL NON-EXEMPT SOLV):0.61 LBS/GAL
-----------------------------
OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG.
-----------------------------
HARMFUL/FATAL. CHLOROCARBON MATLS HAVE
-----------------------------
COULD HAVE SIMILAR EFT IN HUMANS.
-----------------------------
FOR LIFE-SUSTAINING USES IN HUMANS
-----------------------------
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: MAY CAUSE EYE BURNS. HARMFUL IS SWALLOWED. MAY CAUSE NOSE
& THROAT IRRIT. CAN BE ABSORBED THRU SKIN. MAY CAUSE ALLERGIC SKIN RXN.
CAUSES SKIN BURNS. MAY CAUSE LUNG INJURY. MAY AFFECT BRAIN/NERVOUS SYS ,
CAUSING DIZZ, HDCH/NAUS. HARMFUL IF INHALED. EFTS MAY INCL: ANESTH, NAUS,
DRYNESS OF MOUTH, ASTHMA(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: DERM, IRREG HEARTBEAT, INTOX,
UNCON, SHORT OF BRTH, DROW, INFLAMM OF MUC MEMBS OF NOSE & THROAT, BURNS
TO MOUTH, THROAT & ESOPHAGUS, WHEEZING, NARCOSIS, VOMITING, WEAKNESS,
DIARRHEA, ABDOM P AIN, SWELLING & REDNESS OF SKIN. RPTD OVEREXP TO PROD
MAY CAUSE SKIN SENSIT, LIVER ABNORMS, CARD ABNORMS, (SUPDAT)
Medical Cond Aggravated By Exposure: SKIN DISORDERS, PULMONARY CONDITIONS.
First Aid: SKIN: FLUSH W/WATER FOR AT LEAST 15 MINS & GET MED ATTN. REMOVE
CONTAMD CLTHG & WASH BEFORE REUSE. REMOVE CONTAMD CLTHG & WASH BEFORE
REUSE. REMOVE & DESTROY CONTAMD SHOES. EYE: FLUSH W/WATER FOR AT L EAST
15 MINS & GET MED ATTN. INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING,
GIVE ARTF RESP, PREF MOUTH-TO-MOUTH. IF BRTHG IS DFCLT, GIVE O*2. GET MED
ATTN. INGEST: GET MED ATTN IMMEDIATELY(FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION. WEAR APPROPRIATE
SAFETY EQUIPMENT AS LISTED. ABSORB ON INERT MATERIAL & DISPOSE OF AS
BELOW.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS. INCINERATION IS THE PREFERRED METHOD OF DISPOSAL.
Handling And Storage Precautions: KEEP CNTNRS CLSD WHEN NOT IN USE. ALL EQUIP
SHOULD BE GROUNDED. STORE AWAY FROM IGNIT SOURCES. STORE IN WELL-VENT AREA.
DO NOT STORE IN ALUMINUM.
Other Precautions: STORE IN CLEAN, DRY AREA. EMPTY CNTNR MAY RETAIN PRODUCT
RESIDES (VAPOR/LIQUID). ALL PRECS MUST BE OBSERVED. NO SMOKING IN AREA OF
USE. DO NOT USE IN GENL VICIN OF ARC WELDING, OPEN FLAMES/HOT SURFS.HEAT
&/UV RADIA MAY CAUSE (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: CC
Flash Point Text: 97.0F,36.1C
Lower Limits: 1.70%
Extinguishing Media: FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPRVD PRESS DEMAND SCBA & FULL
PROT EQUIP(FP N). WATER MAY BE INEFTIVE IN FIGHTING FIRE. IF WATER IS USED TO
COOL CLSD CNTNRS TO PVNT (SUP DAT)
Unusual Fire/Explosion Hazard: DURING EMER CNDTNS, OVEREXP TO DECOMP PRODS MAY
CAUSE HLTH HAZ; SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MD ATTN. THERM DECOMP
PRODS MAY INCL HCL/PHOSGENE(FP N).
=======================================================
Control Measures
=======================================================
Respiratory Protection: WEAR AN APPROP PROPERLY FITTED RESP (NIOSH/MSHA APPRVD)
DURING APPLICATION & HNDLG UNLESS AIR MONITORING DEMONSTRATES VAP/MIST
LEVELS BELOW APPLIC LIMITS. FOLLOW RESPIRATOR MFR'S RECOM FOR SELECTION A ND
USE.
Ventilation: SUFF VENT MUST BE PROVIDED TO MAINTAIN AIRBORNE CONCS BELOW TLV,
PEL & LEL LIMITS AS LISTED.
Other Protective Equipment: EMERGENCY EYEWASH & DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA(FP N). RUBBER APRON SHOULD BE WORN.
Work Hygienic Practices: GOOD PERS HYGIENE PRACT ARE REQD AT ALL TIMES WHEN
HNDLG CHEMS. THESE PRACT INCL, BUT ARE NOT LIM TO, WASHING(SUPDAT)
Supplemental Safety and Health: FIRE FIGHT PROC: PRESS BUILD-UP, FOG NOZZ ARE
IS RE MOVED, AT THE END OF EACH SHIFT/WHEN GOING ON BREAKS & ESPECIALLY
IF CONTAM OCCURS. EFTS OF OVEREXP: KIDNEY DMG,
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >165F,>74C
Vapor Pres: SEE ING
Vapor Density: HVR/AIR
Spec Gravity: 1.2
Evaporation Rate & Reference: SLOWER THAN ETHER
Appearance and Odor: LIQUID.
Percent Volatiles by Volume: 93.29
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: OPEN FLAME, HEAT, SPARKS.
Materials To Avoid: ALUMINUM, WATER, EPOXY RESINS, KETONES, ZINC, ORGANIC
HALIDES, ACIDS, EPOXIDES, OXIDIZERS, ALDEHYDES.
Hazardous Decomposition Products: CHLORINE, OXIDES OF NITROGEN, PHOSGENE,
OXIDES OF CARBON, SILICON DIOXIDE, HYDROGEN CHLORIDE. HCL, PHOSGENE(FP N).
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: CATALYST FOR 463-6-78, X-515
Cage: 0S4B8
Company Name: CROWN METRO AEROSPACE COATINGS INC SUB OF DEXTER CORP THE
Street: 315 ECHELON RD
PO Box: 5695
Zipcode: 29606
Label Required IND: Y
Date Of Label Review: 12/04/1995
Status Code: C
Label Date: 12/04/1995
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: Severe
Reactivity Hazard: Slight
Hazard And Precautions: FLAMMABLE. DECOMPOSITION PRODUCTS MAY BE HAZARDOUS.
INHAL OF VAPS MAY CONTRIBUTE TO THE OCCURRENCE OF IRREGULAR HEARTBEAT (FP N).
ACUTE: EYES: BURNS. ALLERGIC SKIN RXN, BURNS. LUNG INJURY. BRAIN/NERV SYS
EFTS: DIZZ, HDCH, NAUS. INHAL: ANESTH, NAUS, DRYNESS OF MOUTH, ASTHMA, DERM,
IRREG HEARTBEAT, INTOXICATION, UNCON, SHORTNESS OF BRTH, DROW, INFLAMM OF MUC
MEMBS OF NOSE & THROAT, BURNS TO MOUTH & THROAT & ESOPHAGUS,
WHEEZING, NARCOS, VOMIT, WEAK, DIARR, ABDOM PAIN, SWELL & REDNESS OF
SKIN. CHRONIC: SKIN SENSIT. LIVER, CARDIAC, LUNG, KIDNEY & CNS DMG. MAY
CAUSE PERM BRAIN & NERV SYS DMG. MISUSE MAY BE HARMFUL/FATAL.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:OCEAN FLAYMBAR 477 FIRE RETARDANT EPOXY PAI
Kit Part:Y
CAGE:OCEAN
CAGE:0GU91
CAGE:OCEAN
============= Composition/Information on Ingredients =============
Ingred Name:DIGLYCIDYL ETHER/BISPHENOL A
CAS:25068-38-6
RTECS #:KC2100000
Fraction by Wt: 25-30%
Other REC Limits:NONE SPECIFIED
Ingred Name:DIBUTYL PHTHALATE (SARA III)
CAS:84-74-2
RTECS #:TI0875000
Fraction by Wt: 5-8%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 PPM
ACGIH TLV:5 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:PROPYLENE GLYCOL METHYL ETHER ACETATE
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 3-5%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:100 PPM RECOMMENDED
Ingred Name:HEAVY AROMATIC SOLVENT NAPHTHA
CAS:64742-94-6
Fraction by Wt: 13-17%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:100 PPM RECOMMENDED
Ingred Name:PROPYLENE GLYCOL METHYL ETHER
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 3-5%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:100 PPM RECOMMENDED
Ingred Name:TITANIUM DIOXIDE (NOT CONSIDERED A DUST HAZARD IN PAINT)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 2-10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:VARIOUS PIGMENT (MIXED) (NOT CONSIDERED A DUST HAZARD IN
PAINT)
Fraction by Wt: 0-5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 PPM
ACGIH TLV:10 PPM
Ingred Name:VOC: <250 G/L
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:CURRENTLY NO EVIDENCE OF ADVERSE
EFFECTS RESULTING FROM ROUTINE EXPOSURE. OVEREXPOSURE: HIGH VAPOR
CONCENTRATIONS MAY CAUSE DROWSINESS OR LIGHT-HEADEDNESS. REPORTS
ASSOCIATE REPEATED/PROLONGED OVEREXP OSURE TO SOLVENTS WITH
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. CONCENTRATING & INHALING
VAPORS MAY BE HARMFUL OR FATAL.
======================= First Aid Measures =======================
First Aid:EYE: IMMED FLUSH W/WATER. REMOVE CONTACT LENSES, FLUSH
W/WATER 15 MIN, LIFTING EYELIDS. SEE DR ASAP FOR IMMED FOLLOW UP
TREATMENT. SKIN: RINSE W/SOAP & WATER 5 MIN. IMMED REMOVE & DISCARD
CONTAM CLOTH . MAT'L DIFFICULT TO REMOVE WHEN CURED.SEE DR IF IRRIT
OCCURS AFTER WASHING. INHAL: REMOVE TO FRESH AIR IMMED IF IRRIT
OCCURS. GIVE OXYGEN/ARTIF RESP IF REQ'D. INGEST: IF CONSCIOUS, NOT
CONVULSING **
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:166F,74C
Lower Limits:0.96 @ 93C
Upper Limits:7.59 @ 93C
Extinguishing Media:INORGANIC DRY CHEMICAL EXTINGUISHING COMPOUNDS,
CARBON DIOXIDE, HIGH-EXPANSION CHEMICAL FOAM. *
BY WT
Fire Fighting Procedures:FIRE FIGHTERS WEAR FULL EMERG EQUIP W/SCBA &
PROTECT CLOTH. CNTNRS MAY DEVELOP PRESSURE & BURST W/HEAT. MOVE
CNTNRS FROM FIRE AREA. COOL CNTNRS W/WATER/FOAM.
Unusual Fire/Explosion Hazard:MATERIAL MAY FOAM (INTUMESCE) SEVERELY
UPON HEATING AND LOSS OF SOLVENT DURING EXPOSURE TO FLAMES.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCE. PLACE LEAK CNTNR IN
VENTED AREA. WEAR PROTECT CLOTH & BREATH APPARATUS. CONFINE SPILL &
ABSORB ON SAND, SAWDUST, EARTH, OTHER SOLIDS. DIKE TO PREVENT
ENTRANCE INTO WATER SYS /TABLE. SWEEP & PLACE ABSORBED MAT'L
INCNTNR.
======================Handling and Storage ======================
Handling and Storage Precautions:COMBUSTIBLE. KEEP AWAY FROM HEAT,
SPARKS, OPEN FLAMES. DO NOT BREATHE VAPORS. KEEP CONTAINERS CLOSED
WHEN NOT IN USE. KEEP AWAY FROM CHILDREN.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID CONTACT WITH SKIN. WASH
THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA RESPIRATOR FOR ORGANIC VAPORS (TC23C
OR EQUIV) REQ'D DURING OPEN HANDLING & STANDARD APPLIC. FULL-FACE,
AIR SUPPLIED RESPIRATOR MAY BE NECESSARY FOR EXTENSIVE SPRAY APPLIC
OR FOR PERSONS PA RTICULARLY SENSITIVE TO ODORS/CHEMICALS.
Ventilation:USE LOCAL EXHAUST FANS TO MAINTAIN EXPOSURE BELOW TLV.
MINIMUM 10 AIR-CHANGES/HOUR RECOMMENDED. HANDLE WITH VENT ONLY.
Other Protective Equipment:AS MAY BE NECESSARY TO PREVENT EXCESSIVE
SKIN CONTACT.
Supplemental Safety and Health
KEY1:F8.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:150 TO 165C
Vapor Pres:<20 @25C
Vapor Density:5 - 8
Spec Gravity:1.14 TO 1.26
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE (OR TINTED) OPAQUE LIQUID WITH CHARACTERISTIC
ODOR.
Percent Volatiles by Volume:15-20*
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, WATER, AMINES, ALCOHOLS, STRONG BASES. DO NOT STORE
OR TRANSFER USING COPPER ALLOYS OR ALUMINUM.
Stability Condition to Avoid:DO NOT STORE OR USE IN AREAS WITH OPEN
SOURCES OF IGNITION.
Hazardous Decomposition Products:COMBUSTION PRODUCTS CAN INCLUDE CARBON
OXIDES, NITROGEN OXIDES, AND HYDROGEN CHLORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE SOLIDIFIED WASTE OR BURY IN A
SUITABLE, APPROVED LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1R85 2ND DEVELOPER, BOTTLE 5 OF 6
CAGE:FO108
CAGE:92296
CAGE:FO108
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: <3%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HYDROQUINONE (SARA III)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: <3%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PHENIDONE
CAS:92-43-3
RTECS #:UQ8750000
Fraction by Wt: <0.5%
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: <10%
Ingred Name:SODIUM THIOSULFATE
CAS:540-72-7
RTECS #:XL2275000
Fraction by Wt: <2%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION & ALLERGY. EYES:
IRRITATION & BURNING. INGESTION: BURNING & IRRITATION OF THE MOUTH
& THROAT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION & ALLERGY. EYES: IRRITATION &
BURNING. INGESTION: BURNING & IRRITATION OF THE MOUTH & THROAT.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINUTES & SEEK MED ATTN. SKIN:
FLUSH W/WATER FOR 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING &
SHOES. INHALATION: REMOVE TO FRESH AIR. INGESTION: CALL PHYSICIAN.
DON'T I NDUCE VOMITING.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CO2, FOAM, DRY CHEMICAL
Fire Fighting Procedures:MATERIAL IS NOT COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:THE FRESH SOLUTION CAN BE FLUSHED TO THE SEWER
WITH COPIOUS AMOUNTS OF WTER, IF NECESSARY IT CAN BE ABSORBED WITH
INERT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINERS IN UPRIGHT POSITION.
DON'T LAY ON ENDS OR SIDES. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:AVOID CONTACT W/EYES, SKIN/CLOTHING. WASH HANDS
THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NORMAL WORKING CONDITIONS.
Other Protective Equipment:AS NECESSARY TO PREVENT SKIN CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Vapor Density:0.6
Spec Gravity:1.110
Evaporation Rate & Reference:AS WATER
Solubility in Water:100%
Appearance and Odor:WEAK TAN COLOR W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Hazardous Decomposition Products:SULFUR DIOXIDE FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:STORE IN A CORROSION RESISTANT CONTAINER BEFORE
DISPOSAL. THE SPENT SOLUTION IS TOXIC DUE TO THE PRESENCE OF SILVER
IONS. DON'T FLUSH TO THE SEWER. IT CAN BE NEUTRALIZED WITH OTEHR
BOTTLE SOLUTIONS IF NECESSARY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P16F16
CAGE:JO868
CAGE:JO868
CAGE:00656
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS PE RSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMATIC ODOR.
================= Stability and Reactivity Data =================
STRONG OXIDIZERS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DYCLOMEC 4-G DICHLOBENIL HERBICIDE, 512
Preparer's Name:J.S. SKAPTASON
CAGE:EO416
CAGE:52228
CAGE:EO416
============= Composition/Information on Ingredients =============
Ingred Name:DICHLOBENIL (SARA III)
CAS:1194-65-6
RTECS #:DI3500000
Fraction by Wt: 4%
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RATS): 3,160 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: INACTIVITY, ANOREXIA,
SEDATION, COMA, RESPIRATORY ARREST. SKIN/EYES/INGESTION:
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES/INGESTION: IRRITATION. INHALATION:
INACTIVITY, ANOREXIA, SEDATION, COMA, & RESPIRATORY ARREST.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. INHALATION: MOVE TO FRESH AIR,
INGESTION: GASTRIC LAVAGE. SYMPTOMATIC THERAPY. EYES: WASH W/WATER
FOR AT LEAST 15 MINUTES. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE APPROPRIATE MEDIA.
Fire Fighting Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING. ISOLATE
AREA.
Unusual Fire/Explosion Hazard:HEAT MAY CAUSE RELEASE OF TOXIC
CHLORIDE/NITRIC OXIDE FUMES, RUN OFF FROM WATER MAY CAUSE
POLLUTION.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP AREA. CONTAIN SPILL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE TEMPERATURE BETWEEN -50F TO
140F. AVOID HEAT, LIGHT, MOISTURE, & HIGHLY VOLATILE WHEN HOT. PACK
IN TIGHTLY CLOSED CONTAINERS.
Other Precautions:DON'T STORE NEAR MATERIALS INTENDED FOR HUMAN OR
ANIMAL CONSUMPTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRATOR FOR DUSTS.
Ventilation:PROVIDE ADEQUATE VENTILATION.
Other Protective Equipment:PAPER SUIT, HAND BARRIER CREAM
Supplemental Safety and Health
BULK DENSITY: 36 LBS/CUBIC FT
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>500F
Melt/Freeze Pt:M.P/F.P Text:>280F
Appearance and Odor:AROMATIC
Percent Volatiles by Volume:<20%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DON'T MIX W/WATER SOLUBLE FERTILIZERS OR EMULSIFIABLE HERBICIDES.
Stability Condition to Avoid:DON'T APPLY TO HOT SOILS. HEAT, LIGHT,
MOISTURE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. USE EPA APPROVED DISPOSAL METHODS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1310 WHITE SUPER YACHT ENAMEL, 1310
CAGE:86483
CAGE:86483
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL;(METHYL ALCOHOL) (SARA 313) (CERCLA)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: <1.0%
OSHA PEL:200 PPM, S
ACGIH TLV:200 PPM; 250 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MINERAL SPIRITS
CAS:64742-88-7
Fraction by Wt: 28-30%
OSHA PEL:500 PPM(MFR)
ACGIH TLV:100 PPM(MFR)
Ingred Name:VOLATILE ORGANIC CMPD:(EX WATER/EXEMPT SOLV)420
GM/LITER(3.5 LB/GAL). (IN WATER/EXEMPT SOLV)420 GM/LITER(3.50
LG/GAL).
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: PRLNGD/RPTD CONTACT OF PRODUCT
W/SKIN MAY CAUSE IRRITATION. EYE: DIRECT CONTACT OF PRODUCT WITH
EYES CAN CAUSE IRRITATION. INHAL: VAPOR/MIST CAN CAUSE HEADACHE,
NAUSEA, IRRIT OF NOSE, THROAT & E YES. MAY PRODUCE CNS DEPRESSION.
INGEST: POISONOUS IF SWALLOWED. MAY RESULT IN VOMITING.
ASPIRATION(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: OF VOMITUS INTO LUNGS CAUSES
ASPIRATION PHEUMONITUS. CHRONIC: MAY CAUSE DAMAGE TO THE CENTRAL
NERVOUS SYSTEM, RESPIRATORY SYSTEM, EYES & SKIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:WASH AFFECTED AREAS W/WATER WHILE REMOVING CONTAMD
CLTHG. GET IMMED MD ATTN. LAUNDER CONTAMD CLTHG BEFORE REUSE.
EYES:FLUSH EYES W/GENEROUS AMTS OF WATER FOR AT LEAST 15 MIN. GET
IMMED MD ATTN. I NGEST:DO NOT INDUCE VOMIT. CALL MD IMMED. NEVER
GIVE FLUIDS/INDUCE VOMIT IF VICTIM IS UNCON/HAVING CONVULSIONS.
INHAL: MOVE TO FRESH AIR. AID BRTHG, IF NEC & GET IMMED MD ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:105F,41C
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT. BLANKET VAPOR WITH EXTINGUISHING MEDIA.
Unusual Fire/Explosion Hazard:FLAMMABLE VAPOR CAN FORM EXPLOSIVE
MIXTURE WITH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:SPILLS SHOULD BE CONTAINED, SOLIDIFIED &
PLACED IN RCRA LICENSED FACILITY. HNDLG EQUIP TO BE GROUNDED TO
PREVENT SPARKING. WEAR RESPIRATORS, EYES & SKIN PROTECTION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR
WHEN VAPORS ARE GENERATED ABOVE THE PERMISSABLE LIMIT.
Ventilation:LOCAL EXHAUST TO CONTROL TO RECOMMENDED P.E.L.
Other Protective Equipment:EYEWASH FOUNTAINS SHOULD BE EASILY
ACCESSIBLE. APRONS, BOOTS AS NECESSARY TO PREVENT SKIN CONTACT.
Work Hygienic Practices:SHOWER AFTER HANDLING PRODUCT. CLEAN CLOTHING
SHOULD BE WORN DAILY.
Supplemental Safety and Health
WASTE DISP METHS: CRUSHING/OTHER MEANS TO PREVENT UNAUTHORIZED REUSE.
OTHER CONTAINERS MUST BE DISPOSED OF IN RCRA LICENSED FACILITY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:308F,153C
Vapor Pres:2.1
Vapor Density:3.5
Spec Gravity:1.2
Evaporation Rate & Reference:<1 (BUAC=1)
Solubility in Water:NEGIGIBLE
Appearance and Odor:WHITE VISCOUS LIQUID W/MILD AROMATIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING, REDUCING AGENTS IN CONJUNCTION WITH HEAT,
POLYMERIZATION INITIATORS.
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPARKS OR DIRECT
SUNLIGHT.
Hazardous Decomposition Products:OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCIN IN A RCRA LICENSED FACILITY. DO NOT
DISCHARGE INTO WATERWAYS/SEWER SYSTEMS. DISP OF I/A/W LOCAL, STATE
& FEDERAL REGS. CNTNR DISP: EMPTY CNTNRS W/NO RESIDUE AT ALL MAY BE
LANDFILLED AT LIC ENSED FACILITY OR FOR RECONDITION. RECOMM
(SUPDAT)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KODAK RAPID FIXER CAT#: 128 2839, WORKING SOLUTION (FILM)
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 80-85% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 10-15% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM ACETATE
CAS:127-09-3
RTECS #:AJ4300010
Fraction by Wt: 1-5% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG BORATES/M3
ACGIH TLV:5 MG BORATES/M3
Ingred Name:AMMONIUM SULFITE (SARA III)
CAS:10196-04-0
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID (SARA III)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN FOR WORKING SOLUTION
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY CAUSE TRANSIENT EYE IRRITATION. LOW
SKIN CONTACT HAZARD FOR RECOMMENDED HANDLING. EXPECTED TO BE A LOW
INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMEEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSTION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:MAY REQUIRE NEUTRALIZATION. FLUSH TO SEWER IF
ALLOWABLE WITH LARGE AMOUNTS OF WATER. OTHERWISE, ABSORB SPILL WITH
VERMICULITE OR OTHER INERT MATERIAL, THEN PLACE IN A CONTAINER FOR
CHEMICAL WASTE. CLE AN SURFACE TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING. KEEP FROM CONTACT WITH OXIDIZING
MATERIALS. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:KEEP AWAY FROM INCOMPATIBLE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:C3
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.09
pH:4.4
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, SLIGHT SULFUR DIOXIDE ODOR
Percent Volatiles by Volume:80-85%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, SODIUM HYPOCHLORITE (BLEACH), STRONG OXIDIZING AGENTS, STRONG
ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AMMONIA, NITROGEN OXIDES, SULFUR
DIOXIDE, CHLORAMINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND L OCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EASY DOES IT ALL PURPOSE CLEANER
CAGE:FO612
CAGE:FO612
CAGE:1DA29
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: REDNESS, IRRITATION, BURNING.
SKIN: IRRITATION, REDNESS. INGESTION: BURNING, IRRITATION, NAUSEA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: REDNESS, IRRITATION, BURNING. SKIN:
IRRITATION, REDNESS. INGESTION: BURNING, IRRITATION, NAUSEA.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER 15 MIN, LIFTING EYELID.
INGESTION: GIVE SEVERAL GLASSES OF WATER OR MILK. NEVER GIVE
LIQUIDS TO UNCONSCIOUS PERSON. SKIN: FLUSH WITH PLENTY OF WATER 15
MIN. SEE PHYSICIAN .
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE MEDIA PROPER TO THE PRIMARY CAUSE OF FIRE.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP OR MOP UP, RINSE AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL GOOD HOUSEKEEPING PRACTICES TO
PREVENT SPILLS.
Other Precautions:KEEP OUT OF THE REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Ventilation:MECHANICAL EXHAUST: SATISFACTORY
Other Protective Equipment:OTHER PROTECTIVE EQUIPMENT AS NEEDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:<30
Spec Gravity:10.4
Evaporation Rate & Reference:(BU AC = 1): <0.4
Solubility in Water:COMPLETE
Appearance and Odor:PINK LIQUID, CITRUS FRAGRANCE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & OXIDIZERS
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH TO SEWER, IF PERMITTED BY FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STERLING SNOW & ICE CONTROL SALT
Preparer's Name:T.E. DOMMER
CAGE:KO152
CAGE:KO152
CAGE:0HX06
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM FERROCYANIDE
CAS:13601-19-9
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV ORAL=3.75G/KG/MLD I.V.=2.5G/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:NO ACUTE/CHRONIC SYSTEMIC OR CHRONIC LOCAL
TOXICITY. IN SENSITIVE PERSONS, SOME SKIN/EYE IRRITATION. AFTER
EXCESSIVE INGESTION, EDEMA OR TEMPORARILY ELEVATED BLOOD PRESSURE
EFFECTS.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:SKIN/EYES: FLUSH W/WATER AT LEAST 15 MINUTES. GET MED AID IF
IRRITATION PERSISTS. INGESTION: HIGH FLUID INTAKE FACILITATES
URINARY EXCRETION & RELIEF OF EDEMA & TEMPORARILY ELEVATED BLOOD
PRESSURE. MA Y INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:NONE
Fire Fighting Procedures:NONE. NOT COMBUSTIBLE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:NON-HAZARDOUS, NON-CORROSIVE. SWEEP UP & FLUSH
W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE UNDER DRY CONDITIONS TO PREVENT
CAKING OF SALT. STORE UNDER PROTECTIVE COVER WHENEVER POSSIBLE.
Other Precautions:NO
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NECESSARY.
Ventilation:NOT NECESSARY
Work Hygienic Practices:WASH HANDS AFTER HANDLING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:147F,64C
Vapor Pres:[email protected]
Vapor Density:NA
Spec Gravity:2.165
Evaporation Rate & Reference:NA
Solubility in Water:35.7 @ 0, 36 @ 20
Appearance and Odor:SOLID WHITE, OR OFF-WHITE CRYSTALINE MATERIAL,
ODORLESS
Percent Volatiles by Volume:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONCENTRATED ACIDS SUCH AS SULFURIC OR NITRIC.
Hazardous Decomposition Products:HYDROCHLORIC ACID FROM ABOVE ACID
MIXTURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:TRY TO LANDFILL OR DISSOLVE IN SUFFICIENT
AMOUNTS WATER TO MEET LOCAL EXISTING WATER QUALITY STANDARDS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P-4 BLEACH BL 4.25 PART A 4.17 LITERS
Kit Part:Y
CAGE:64145
CAGE:64145
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID (CONFIRMED HUMAN CARCINOGEN BY IARC - GROUP
1) *96-1*
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 15-30%
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM=IC
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENESULFONIC ACID, M-NITRO-, SODIUM SALT,
M-NITROBENZENESULFONIC ACID SODIUM SALT
CAS:127-68-4
RTECS #:DB7195000
Fraction by Wt: 5-7%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 65-70%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 155 MG/KG SULFURIC ACID
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: CORROSIVE, CAUSES IRREVERSIBLE
DAMAGE & BLINDNESS. SKIN: CORROSIVE, CAUSES BURNS TO MUCOUS
MEMBRANES. INHALATION: MIST IS IRRITANT TO UPPER RESPIRATORY TRACT.
MAY CAUSE PULMONARY EDEMA, COUGHING & SNEEZING. INGESTION: DENTAL
EROSION,BURNS TO MOUTH, THROAT, ESOPHAGUS & STOMACH. (SEE SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:BURNS, IRRITANT, EDEMA, COUGHING, SNEEZING,
INFECTIONS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: FLUSH W/WATER THEN
WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR & PERFORM
ARTIFICIAL RESPIRATION. INGESTION: GIVE 4-5 GLASSES OF MILK/WATER.
DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE MEDIA PROPER TO PRIMARY SOURCE OF FIRE.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:MAY PRODUCE TOXIC FUMES. ACTS AS AN
OXIDIZER.
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE. RINSE NEUTRALIZED SOLUTION TO
SEWER IF PERMITTED BY LOCAL AUTHORITIES.
Neutralizing Agent:SODIUM CARBONATE/BAKING SODA.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY AREA AWAY FROM
DEVELOPERS, FIXER & STRONG ALKALIS. USE W/ADEQUATE VENTILATION.
Other Precautions:AVOID INHALATION & CONTACT W/SKIN, EYES & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED ACID GAS/ORGANIC VAPOR
RESPIRATOR IF SUFFICIENT VENTILATION ISN'T PROVIDED.
Ventilation:LOCAL EXHAUST: CHANGE MACHINE FILTER AS RECOMMENDED.
MECHANICAL VENTILATION: GOOD ROOM VENTILATION.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
HEALTH & SYMPTOMS CON'TD: CHRONIC: INHALATION: MIST/VAPOR CAUSES
BRONCHITIS, FREQUENT RESPIRATORY INFECTIONS, EMPHYSEMA.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Melt/Freeze Pt:M.P/F.P Text:>32F
Vapor Pres:AS WATER
Vapor Density:AS WATER
Spec Gravity:1.21
pH:<1
Evaporation Rate & Reference:AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW LIQUID W/CHARACTERISTIC ODOR.
Percent Volatiles by Volume:69/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DEVELOPERS, FIXERS, SULFITES
Hazardous Decomposition Products:SULFUR DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:SOLUTION IS RCRA HAZARDOUS WASTE UNLESS
NEUTRALIZED TO PH 6-8 BEFORE DISPOSAL. BY PERMIT, MAY BE DISCHARGED
TO SANITARY SEWER AFTER NEUTRALIZATION. DISPOSE OF IAW/FEDERAL,
STATE & LOCAL REGULATIONS. C ORROSIVE MATERIAL, UN1830.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SEL-REX XR-235B ADDITION AGENT, DCAS
Preparer's Name:HT BORDEN
CAGE:GO075
CAGE:GO075
CAGE:02258
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >90%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SULFURIC ACID (SARA 302/313) (CERCLA)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: <10%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/3 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:FORMALDEHYDE (SARA 302/313) (CERCLA)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: <0.05%
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM, A2
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:NON-HAZARDOUS INGREDIENTS (REMAINDER OF INGREDIENTS NOT
KNOWN TO BE HAZARDOUS)
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:MIST OR VAPOR MAY
IRRITATE RESPIRATORY TRACT. INGESTION:CAN CAUSE SEVERE BURNS TO
MOUTH, ESOPHAGUS AND STOMACH. SKIN:CAN CAUSE SEVERE BURNS.
EYES:CAUSES SEVERE BURNS WITH DAMAGE TO EY ES AND POSSIBLE
BLINDNESS. CHRONIC:THISPRODUCT CONTAINS LESS THAN 0.1%
FORMALDEHYDE. FORMALDEHYDE MAY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SULFURIC ACID:IARC MONOGRAPHS ON EVAL OF
CARCIN RISK OF CHEMS TO MAN, VOL 54, PG 41, 1992:GROUP 1.
ANIMAL:PULM IRRIT.
Effects of Overexposure:HLTH HAZS:CAUSE SENSITIZATION AND REDUCED
VISION. LIFETIME STUDY OF RATS EXPOSED TO FORMALDEHYDE GAS
INDICATED DEVELOPMENT OF NASAL CANCER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM CONTAM AREA. IF BRTHG HAS STOPPED,
RESUSCITATE & ADMIN OXYG IF AVAIL. SEEK IMMED MED ATTN.
INGEST:NEVER GIVE ANYTHING BY MOUTH TO AN UNCON PERSON, OBTAIN
IMMED MED ATTN. IF VOMIT OCC URS SPONT, KEEP AIRWAY CLEAR.DO NOT
INDUCE VOMIT, GIVE LG AMTS OF WATER. SEEK IMMED MED ATTN.
SKIN:IMMED WASH W/PLENTY OF SOAP & WATER. REMOVE CONTAM CLTHG &
FOOTWEAR. WASH CLTHG BEFORE (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NOT COMBUSTIBLE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . KEEP CONTAINERS COOL TO PREVENT RUPTURE AND
RELEASE OF MATERIAL.
Unusual Fire/Explosion Hazard:HYDROGEN, A HIGHLY FLAMMABLE AND
EXPLOSIVE GAS, MAY BE GENERATED BY THE ACTION OF ACIDS AND MANY
METALS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROT EQUIP, INCLUDING NIOSH/MSHA APPRVD
SCBA. SWEEP/SHOVEL SPILLED MATL INTO CLEAN STEEL DRUM & COVER.
CAREFULLY FLUSH SPILL AREA W/WATER & RECOVER RESULTANT SOLN/SLURRY
FOR DISP. KEEP OUT OF SEW ER. DISP OF IN ACCORD W/LOC, STATE & FED
REGS.
Neutralizing Agent:NEUT DILUTE RESIDUE W/ALKALI SUCH AS SODA ASH,
LIME/LIMESTONE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP AWAY
FROM ALKALIES AND OXIDIZERS. LOOSEN COVER CAUTIOUSLY WHEN OPENING.
Other Precautions:STORE ABOVE FREEZING TEMPERATURE. AVOID CONTACT WITH
SKIN, EYES AND CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WHEN AIR
CONCENTRATION IS GREATER THAN THE TLV OR PEL. USE NIOSH/MSHA
APPROVED CARTRIDGE FILTER FOR ACID MIST.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . WEAR FULL PROTECTIVE WORK CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRST AID PROC:REUSE. DISCARD FOOTWEAR IF IT CANNOT BE DECONTAM. SEEK
IMMED MED ATTN. EYES:IMMED FLUSH W/PLENTY OF WATER FOR AT LST 15
MIN HOLDING LIDS APART TO ENSURE FLUSHING OF ENTIRE SURF. WASHING
W/IN SEVERAL SECONDS OF EXPOS IS ESSNTL TO MIN DMG. SEEK IMMED MED
ATTN. EYE PROT:AND FULL LENGTH FSHLD .
================== Physical/Chemical Properties ==================
Spec Gravity:1.03 (H*2O=1)
pH:<1
Solubility in Water:100%
Appearance and Odor:CLEAR TO SLIGHT YELLOW LIQUID WITH A SLIGHT MUSTY
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIES, STRONG BASES, OXIDIZERS.
Stability Condition to Avoid:SEE MATERIALS TO AVOID.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOR WASTE DISPOSAL INFORMATION CONSULT MFR.
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: AZ-0400 CA UNIV GRAY PRIMER AZ-COTE ALL TOPCOATS & PRIMERS
Cage: OADX8
=======================================================
Contractor Summary
=======================================================
Cage: OADX8
=======================================================
Ingredients
=======================================================
Cas: 64741-41-9
% low Wt: 25.
% high Wt: 50.
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Effects of Exposure: MAY BE IRRITATING TO THE EYES & RESPIRATORY TRACT. MAY
CAUSE NERVOUS SYSTEM EFFECTS & DEATH. ANESTHETIC. LOW ORAL & DERMAL
TOXICITY. INGESTION: MINUTE AMOUNTS ASPIRATED INTO THE LUNGS DURING INGESTION
/VOMITING MAY CAUSE MILD TO SEVERE PULMONARY INJURY & POSSIBLY DEATH.
CHRONIC EXPOSURE MAY CAUSE DAMAGE TO THE CNS, RESPIRATORY SYSTEM, LUNGS,
EYES, SKIN, LIVER, GI TRACT, SPLEEN, KIDNEYS & BLOOD. REP EATED/PROLONGED
OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE
CONTENTS MAY BE HARMFUL/FATAL.
Signs And Symptions Of Overexposure: IRRITATION, HEADACHE, DIZZINESS,
DROWSINESS, UNCONSCIOUSNESS, VOMITING.
First Aid: INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. TREAT
SYMPTOMATICALLY. EYES: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR 15
MINS. SKIN: WIPE OFF W/TOWEL. WASH W/SOAP & WATER. INGESTION: REMOVE
STOMACH CONTENTS BY GASTRIC SUCTION/INDUCE VOMITING ONLY AS DIRECTED BY A
MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH IF UNCONSCIOUS. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION, FLAMES, HOT SURFACES,
ELECTRICAL, STATIC/FRICTIONAL SPARKS. AVOID BREATHING VAPORS. VENTILATE AREA.
USE NON-SPARKING TOOLS. REMOVE W/INERT ABSORBENT.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
Handling And Storage Precautions: DON'T STORE NEAR HEAT, SPARKS/FLAME.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point: =38.9C, 102.F
Extinguishing Media: CO2, DRY CHEMICAL, FIRE FOAM
Fire Fighting Procedures: WATER IS UNSUITABLE, BUT MAY BE USED TO COOL CLOSED
CONTAINERS.
Unusual Fire/Explosion Hazard: KEEP AWAY FROM HEAT, SPARKS & FLAME.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IN CONFINED AREAS OF POOR VENTILATION, USE CHEMICAL
CARTRIDGE RESPIRATOR/SELF CONTAINED BREATHING APPARATUS.
Ventilation: GENERAL DILUTION/LOCAL EXHAUST IN VOLUME & PATTERN TO KEEP TLV
& LEL OF MOST INGREDIENTS BELOW ACCEPTABLE LIMIT.
Other Protective Equipment: NONE
Work Hygienic Practices: REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES BEFORE
REUSE.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 311-380F
Vapor Density: >1
Evaporation Rate & Reference: SLOWER THAN ETHER
Percent Volatiles by Volume: 53.87-63.82
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, SPARKS, FLAMES, HOT SURFACES, ELECTRICAL,
STATIC/FRICTIONAL SPARKS
Hazardous Decomposition Products: FIRE, BURNING & WELDING MAY GENERATE CO.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: FIRE, BURNING, WELDING.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: AZ-0400 CA UNIV GRAY PRIMER AZ-COTE ALL TOPCOATS & PRIMERS
Cage: OADX8
Assigned IND: Y
Company Name: DIAMOND VOGEL PAINT
Street: 1020 ALBANY PLACE SOUTH
Zipcode: 51041
Label Required IND: Y
Date Of Label Review: 09/14/1999
Status Code: A
Origination Code: G
=======================================================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:HI HIDE WHITE UNDERCOAT,MO-210 (A-628)
CAGE:EO463
CAGE:71191
CAGE:EO463
============= Composition/Information on Ingredients =============
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BUTANOL (CAS# 71-36-3)
ACGIH TLV:S,C 50 PPM
Ingred Name:AMSCO SOLVENT B
ACGIH TLV:100 PPM (MFR)
Ingred Name:AMSCO SOLVENT G (SEE SUPP DATA FOR OTHER INGREDIENTS)
ACGIH TLV:200 PPM (MFR)
===================== Hazards Identification =====================
Effects of Overexposure:VAPOR IRRITANT TO EYE,NOSE,THROAT.HIGH
CONCENTRATIONS CAUSE DROWSINESS,DIZZINESS,FOLLOWED BY COMA.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH IMMED W/PLENTY OF H*20 FOR @ LEAST 15 MIN,CALL
DR.SKIN:WASH W/SOAP & H*2O.WASH CONTAM CLTHG BEFORE
REUSE.INGEST:CALL DR IMMED.DO NOT INDUCE VOMITING.INHAL:REMOVE TO
FRESH AIR.IF NOT BREATHIN G GIVE ARTIFICIAL RESP(MOUTH TO
MOUTH).CALL DR.
===================== Fire Fighting Measures =====================
Flash Point:68F (Z0C),TCC
Extinguishing Media:H*20 FOG,FOAM,DRY CHEMICAL/CO*2
Fire Fighting Procedures:USE AIR SUPPLIED EQUIP IN ENCLSD AREA,COOL EXP
CNTNRS W/H*20
Unusual Fire/Explosion Hazard:KEEP AWAY FROM HEAT,SPARKS/OPEN FLAMES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION
SOURCES(FLAME;ELECTRIC,STATIC/FRICTIONAL SPARKS;HOT SURFACES).AVOID
BREATHING VAPORS.VENT AREA.CONTAIN & SCOOP UP SPILL W/NON-SPARKING
TOOLS,RAGS,ETC.USE INERT ABSORBENT MATL ON SM ALL SPILL/ON
RESIDUALS OF LARGE SPILLS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED & UP RIGHT TO
PVNT LEAK.AVOID FLAMES,WELDING,SMOKING,SPARKS,OPEN LIGHTS,ETC.AVOID
BREATHING OF VAPOR OR SPRAY MIST.
Other Precautions:AVOID EYE + SKIN CONTACT.MAINTAIN GOOD PERSNAL
HYGIENE.DO NOT USE IN CONFINED AREAS,TANK/PIT WITHOUT ADEQUATE
VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA ORGANIC VAPOR CANISTER/AIR SUPPLIED
FACE MASKS.
Ventilation:LOCAL EXHAUST & MECHANICAL VANTILATION.
Supplemental Safety and Health
OTHER INGRED:LEAD IN DRIER,TLV=0.15 MG/CUM (MFR);SO-355L,TLV=80 PPM
(MFR). DATE OF PREP:JANUARY,1980.
================== Physical/Chemical Properties ==================
Spec Gravity:1.5144
Evaporation Rate & Reference:FASTER THAN NBUAC
Appearance and Odor:WHITE VISCOUS LIQUID W/SOLVENT ODOR.
Percent Volatiles by Volume:55
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: MAINTENANCE FORMULA
Cage: 50505
Proprietary Ind: Y
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 50505
Box: 123
=======================================================
Contractor Summary
=======================================================
Cage: 50505
Box: 123
Cage: 8Z372
Box: UNKNOW
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: ORAL LD50(RAT): 8.0 G/KG ARMEX
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: MAY CAUSE IRRITATION DUE TO MECHANICAL ACTION.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, DISCOMFORT.
Medical Cond Aggravated By Exposure: PRE-EXISTING UPPER RESPIRATORY & LUNG
DISORDERS.
First Aid: EYES: REMOVE CONTACT LENSES. FLUSH W/CLEAN FLOWING WATER, LOW
PRESSURE & LUKEWARM IF POSSIBLE. SKIN: WASH THOROUGHLY W/SOAP/MILD
DETERGENT & LARGE AMOUNTS OF WATER. INGESTION: GIVE WATER TO DRINK. DON
'T GIVE ANYTHING TO AN UNCONSCIOUS PERSON. INHALATION: REMOVE TO FRESH AIR.
TREAT SYMPTOMATICALLY. OBTAIN MEDICAL ATTENTION IN ALL CASE. (SEE SUPP)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SCOOP INTO CLEAN, DRY CONTAINERS FOR DISPOSAL. WASH
AWAY RESIDUE W/WATER.
Waste Disposal Methods: BURY IN A SECURED LANDFILL IAW/FEDERAL, STATE &
LOCAL REGULATIONS. EMPTY CONTAINERS MAY BE INCINERATED/DISCARDED AS GENERAL
TRASH. ARMEX BLAST MEDIA WASTE MAY BE DILUTED W/A LARGE AMOUNT OF WATER &
SE WERED.
Handling And Storage Precautions: STORE IN ORIGINAL CONTAINERS IN A COOL, DRY
AREA AWAY FROM INCOMPATIBLE MATERIALS. WEAR APPROVED DUST MASK DURING
USE/HANDLING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NON-FLAMMABLE
Extinguishing Media: USE EXTINGUISHING MEDIA FOR SURROUNDING FIRE.
Fire Fighting Procedures: WEAR SCBA & FULL PROTECTIVE EQUIPMENT (BUNKER
GEAR).
Unusual Fire/Explosion Hazard: NON-FLAMMABLE/NON-COMBUSTIBLE. STATIC SPARKS MAY
BE GENERATED DURING THE BLASTING OPERATION.
=======================================================
Control Measures
=======================================================
Respiratory Protection: WEAR A NIOSH APPROVED DUST FILTER MASK FOR GENERAL
EXPOSURE TO ARMEX DUSTS & OUTDOOR BLASTING OF NON-HAZARDOUS COATINGS. USE
AN ABRASIVE BLASTING BLASTING RESPIRATOR FOR INDOOR/ENCLOSED WORK &
COATING S.
Other Protective Equipment: FULL COVER CLOTHING, APRONS/IMPERVIOUS COVER.
Supplemental Safety and Health: NOTE TO PHYSICIAN: INGESTION OF LARGE AMOUNTS
MAY CAUSE SYSTEMIC ALKALOSIS. TREATMENT BASED ON JUDGEMENT OF PHYSICIAN IN
RESPONSE TO REACTIONS OF PATIENT.
=======================================================
Physical/Chemical Properties
=======================================================
PH: (SUPP)
Solubility in Water: 8.6 G/100ML
Appearance and Odor: SOLID WHITE CRYSTALLINE POWDER
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: TEMPS >228F, MOISTURE.
Materials To Avoid: ACIDS, CAUSTIC, CALCIUM OXIDE.
Hazardous Decomposition Products: CO2. THERMAL: SODIUM OXIDE.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: MAINTENANCE FORMULA
Cage: 50505
Company Name: CHURCH AND DWIGHT CO INC
Street: UNKNOWN
PO Box: 123
Zipcode: 82935-0123
Label Required IND: Y
Date Of Label Review: 10/12/1999
Status Code: A
Origination Code: G
Hazard And Precautions: EYES: MAY CAUSE IRRITATION DUE TO MECHANICAL ACTION.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TURCOFORM MASK 505
CAGE:D9808
CAGE:61102
CAGE:D9808
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 50.0%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DISULFIRAM
CAS:97-77-8
RTECS #:JO1225000
Fraction by Wt: <0.5%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
===================== Hazards Identification =====================
Effects of Overexposure:INH:HEAD,NOSE/THROAT IRRIT;EYES:SEV IRRIT MAY
DAMAGE PERMANTLY;SKIN:IRRIT,DEFATNG,MAY ABSORB TOX AMT
======================= First Aid Measures =======================
First Aid:SKIN:WASH W SOAP & WATER,GET MED ATTN IF IRRIT/BLISTRNG
OCCUR;EYES:FLUSH W LG VOL OF WATER;INH:REMOVE TO FRESH AIR,GIVE
CPR/OXYGEN IF NECESS;ING:DO NOT INDUCE VOMIT,GIVE LG VOL OF
MILK/WATER;CALL PHYS FOR ANY OF ABOVE PROBLEM;TAKE TO HOSP IF
NECESSAR
===================== Fire Fighting Measures =====================
Flash Point:40F SCC
Lower Limits:UNK
Upper Limits:UNK
Extinguishing Media:CO*2,FOAM,DRY CHEM
Fire Fighting Procedures:USE SELF-CNTND BRTHG APP
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA.WEAR PROTECTVE EQUIP.ELEMINATE
IGN SOURCE.STOP LEAK W/O RISK.DIKE/CONTAIN SPILLAGE.WIPE UP OR
ABSORB SPILLAGE ONTO ABSORBENT MATL.RECOVER IN DRUMS/CONTNRS WHICH
ARE SUITABLE FOR SHIPMEN T TO DISPOSAL LOCATION.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT/IGN SOURCES.USE
CARE IN OPENING DRUMS TO AVOID SPURTING OF CONTENTS.PROTECT CONTNRS
AGAINST PHYSICAL DAMAGE.
Other Precautions:VAP HEAVR THAN AIR WILL TRAVL ALONG GRD COLLECTING IN
LOW AREAS SUCH AS SUMPS.PERSONS ENTERING THIS AREA SHOULD USE
PROTEC EQUIP & BE OBSERVD WHILE IN THE AREA;AVOID REPEATD CONT W
SKIN/EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF-CNTND BRTG APP,POSS PRESSURE HOSE
MASK/AIR-LINE MASK W/FACEPIEC
Ventilation:LOCAL EXHAUST TO MINIMIZE VAPOR CONCENTRATION
Other Protective Equipment:SOLVENT RESISTANT BOOTS & APRON (NEOPRENE).
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:231F(TOLUEN
Vapor Pres:<1
Vapor Density:>1.0
Spec Gravity:1.01
Evaporation Rate & Reference:<1.0 (BU-ACETATE)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK VISCOUS LIQUID,AROMATIC ODOR.
Percent Volatiles by Volume:60.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:SOURCE OF IGNITION
Hazardous Decomposition Products:TOXIC OXIDES OF CARBON/NITROGEN,CARBON
MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:MFGR RECOMMENDS ONE OR ALL OF THE FOLLOWING
METHODS:(1) INCINERATE IN AN APPROVED INCIN. W APPROP. FUME
SCRUBBER;(2) LANDFILL IAW LOCAL,STATE,FED REGS;(3) TRANSFER /SHIP
TO RECLAIMING FACILITY FOR SOL VENT RECOVERY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PLIOBOND 20
CAGE:Z1291
CAGE:Z1291
============= Composition/Information on Ingredients =============
Ingred Name:SYNTHETIC RUBBER; (FORMULATED SYNTHETIC RUBBER)
Fraction by Wt: 10-60%
Ingred Name:PHENOLIC RESIN
Fraction by Wt: 10-60%
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: >60%
OSHA PEL:200 PPM;300 PPM STEL
ACGIH TLV:200 PPM;300 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PHENOL (SARA III)
CAS:108-95-2
RTECS #:SJ3327000
Fraction by Wt: 1-10%
OSHA PEL:5 PPM, S
ACGIH TLV:5 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 1-10%
OSHA PEL:15MG/M3 TDUST;5RDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST: HARMFUL. LOCAL IRRITATION AND
NARCOTIC SYMPTOMS MAY BE EXPECTED. EYE: STRONG IRRITANT. SEVERE
CONJUNCTIVAL IRRITATION AND CORNEAL INJURY MAY RSLT. SOLVENT VAPORS
MAY CAUSE IRRITATION TO EYES. SKIN: HARMFUL. PROLONGED OR REPEATED
CONTACT MAY CAUSE DERMATITIS. INHAL: HIGH CONC OF SOLV VAPS CAN
(EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: BE HARMFUL IN ENCLOSED SPACES.
EXPOSURE TO VAPOR CONCENTRATIONS HIGHER THAN 300 PPM CAUSES ALMOST
INTOLERABLE IRRITATION OF THE MUCOUS MEMBRANES OF THE EYES AN UPPER
RESPIRATORY TRACT, HEADA CHES AND NUMBNESS OF FINGERS AND ARMS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:IF SWALLOWED & IF MORE THAN 15 MIN FROM HOSPITAL
INDUCE VOMIT USING IPECAC SYRUP APF. CONT MD/POISON INFO CENTER.
EYE:HOLD OPEN, FLOOD W/WATER FOR @ LST 15 MINS AND SEE MD. SKIN:
REMOVE CONTAMI NATED CLOTHING AND WASH SKIN THOROUGHLY. INHAL:
REMOVE TO FRESH AIR. IF BREATHING HAS CEASED GIVE ARTIFICIAL
RESPIRATION AND SEEK MEDICAL ADVICE. NOTE TO MD: CONTACT POISON
INFO CENTER.
===================== Fire Fighting Measures =====================
Flash Point:24.8F,-4.0C
Lower Limits:1.8% (MEK)
Upper Limits:11.5% (MEK)
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL RESISTANT
FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER SPRAY TO COOL STORAGE CONTAINERS
EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:PRODUCT IS FLAMMABLE LIQUID CONTAINING
EXTREMELY VOLATILE SOLVENTS. VAPORS CAN TRAVEL GREAT DISTANCES TO
POTENTIAL IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:ISOLATE SPILL AND SOAK UP WITH INERT ABSORBENT
MATERIAL SUCH AS CLAY OR SAND. ALL IGNITION SOURCES SHOULD BE
REMOVED FROM IMMEDIATE AREA. COLLECT ABSORBED MATERIAL AND PLACE IN
SEALED CONTAINER. ENSUR E ADEQUATE VENT DURING CLEAN UP PROCESS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROD IS FLAMM.STORE AS CLASS 3.21 MATL
IN COOL DRY PLACE WELL AWAY FROM ANY SOURCE OF IGNIT/ANY HOT SURF.
KEEP CNTNR TIGHTLY SEALED WHEN NOT IN USE.
Other Precautions:TRANSPORT AS CLASS 3.2 MATL, PACKAGING GRP III.
METHYL ETHYL KETONE & SUBSTANCES CONTAINING MEK SHLD NOT BE USED IN
CONJUNCTION W/OTHER PRODS CONTAINING N-HEXANE, AS CONCURRENT EXPOS
TO BOTH PRODS WIL L ACCELERATE DAM DUE TO (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF USING PRODUCT IN AN ENCLOSED AREA, USE A
NIOSH/MSHA APPROVED 1/2 FACE RESPIRATOR SUITABLE FOR ORGANIC
VAPORS.
Ventilation:USE IN WELL VENTD AREAS & ENSURE VENT IS ADEQ TO MAINTAIN
AIR CONC < TLV'S.USE LOC EXHST VENT (FLAME PROOF) (SUPP DATA)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PREC: N-HEXANE. PRODUCT IS FLAMMABLE AND SHOULD ONLY BE USED IN
WELL VENTILATED AREAS AWAY FROM HEAT, SPARKS, NAKED FLAMES, AND ANY
OTHER IGNITION SOURCES. VENT: IN ENCLOSED AREAS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>176F,>80C
Vapor Pres:72 @ 20C
Spec Gravity:APPROX 0.8
Solubility in Water:PARTIALLY SOLUBLE
Appearance and Odor:STRAW COLORED VISCOUS LIQUID; KETONE ODOR.
Percent Volatiles by Volume:80(WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO*2, HYDROGEN CHLORIDE AND
HYDROCARBONS MAY BE PRODUCED ON COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL GOVERMENT
REGULATION. ADVISE AUTHORITIES OF FLAMMABLE SOLVENT RESIDUES.
DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FPC2024 EPIBOND 156A
Kit Part:Y
Preparer's Name:RAJESH S PATEL
CAGE:02684
CAGE:02684
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL A DIGLYCIDYL ETHER RESIN, EPOXY RESIN, EPON 820,
ARALDITE 6004, AMINE ADDUCT, ARALDITE GY250 *96-4*
CAS:25068-38-6
RTECS #:KD4380000
Ingred Name:DIBUTYL PHTHALATE, DI-N-BUTYL PHTHALATE
CAS:84-74-2
RTECS #:TI0875000
Fraction by Wt: 5%
Other REC Limits:5 MG/CUM
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:SILICA, MICA, MUSCOVITE
CAS:12001-26-2
RTECS #:VV8760000
ACGIH TLV:3 MG/CUM
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*96-4*
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RATS): >5000 MG/KG (SEE SUPP)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION/INGESTION: HARMFUL. EYES:
SLIGHTLY IRRITATING. SKIN: MODERATELY IRRITATING.
PROLONGED/REPEATED EXPOSURE CAN CAUSE ALLERGIC REACTION. MAY CAUSE
BIRTH DEFECTS & REPRODUCTIVE DISORDERS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
Medical Cond Aggravated by Exposure:ALLERGY, ECZEMA/EYE CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/LARGE AMOUNTS
OF WATER FOR 15 MINS. SKIN: WASH THOROUGHLY W/SOAP & WATER.
INGESTION: DILUTE BY GIVING 2 GLASSES OF WATER TO DRINK. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. OBTAINMEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:359.6F
Extinguishing Media:CO2, DRY CHEMICAL, WATER SPRAY, FOAM.
Fire Fighting Procedures:WEAR BREATHING APPARATUS (MSHA/NIOSH APPROVED,
PRESSURE DEMAND, SELF CONTAINED/EQUIVALENT) & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:DECOMPOSITION & COMBUSTION PRODUCTS MAY
BE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP TRACES OF AREA. SHOVEL MATERIAL INTO
DRY, CLEAN CONTAINERS. ON HARD SURFACE USE ABSORBENT MATERIAL TO
PICK UP REMAINDER; ON LOOSE SURFACES SHOVEL UP CONTAMINATED LAYER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT TEMP 95F.
Other Precautions:AVOID SKIN CONTACT. PLEASE READ BEFORE HANDLING THE
PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR RESPIRATOR (MSHA/NIOSH) SUITABLE FOR
CONCENTRATIONS & TYPES OF AIR CONTAMINANTS ENCOUNTERED.
Ventilation:NORMAL ROOM
Other Protective Equipment:SAFETY SHOWER, EYEWASH FACILITY & PROTECTIVE
CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH AREA THOROUGHLY W/SOAP & WATER AFTER HANDLING THIS
MATERIAL.
Supplemental Safety and Health
THE ORAL LD50 INFORMATION IS FOR BISPHENOL A DIGLYCIDYL ETHER RESIN.
NOTES TO PHYSICIAN: ALLERGIC DERMATITIS/RESPIRATORY RESPONSE IN
SUSCEPTABLE INDIVIDUALS MAY BE DELAYED. IT MAY APPEAR AFTER WEEKS/E
VEN MONTHS OF FREQUENT & PROLONGED CONTACT.
================== Physical/Chemical Properties ==================
Vapor Pres:<1
Vapor Density:>1
Spec Gravity:1.5
VOC Pounds/Gallon:10
Evaporation Rate & Reference:(BU AC = 1): <1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN COLOR SOFT PASTE; ODORLESS
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:ELEVATED TEMPS.
Hazardous Decomposition Products:CO, CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN AN APPROVED
EQUIPMENT/LANDFILL/INCINERATE CONTAMINATED MATERIAL IAW/FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TRAFFICOTE FILLER, 5105
CAGE:4Z817
CAGE:4Z817
============= Composition/Information on Ingredients =============
Ingred Name:SILICA; (SILICA FLOUR)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 20-50%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:SILICA; (SILICA SAND)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 50-75%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF INHALED. REPEATED OR
PROLONGED INHALATION MAY CAUSE INJURY TO LUNGS. THIS PRODUCT
CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH
DEFECTS OR OTHER REPRODUCTIVE HARM.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES: IMMEDIATELY FLUSH
W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM
MD . SKIN: AFTER CONTACT, WASH WELL WITH SOAP AND WATER.
===================== Fire Fighting Measures =====================
Upper Limits:0.00%
Extinguishing Media:WILL NOT SUPPORT COMBUSTION. MEDIA SUITABLE FOR
SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE DUSTLESS METHODS: VACUUM INTO A CLOSEABLE
CONTAINER OR FLUSH WITH WATER. DO NOT SWEEP. WEAR PROTECTION
EQUIPMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A DRY AREA.
Other Precautions:USE WITH ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED DUST MASK RESPIRATOR.
Ventilation:USE SUFFICIENT LOCAL EXHAUST TO REDUCE THE DUST BELOW THE
TLV FOR RESPIRABLE QUARTS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR FULL LENGTH CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:0F,-18C
Vapor Density:HVR/AIR
Spec Gravity:2.01441
Evaporation Rate & Reference:SLOWER THAN (N-BU AC)
Appearance and Odor:FLOUR & SAND MIX.
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PREPP ASSOCIATES FOG SPRAY
CAGE:0PG47
CAGE:0PG47
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL, RAT) >5000 MG/M3
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:FOR STODDARD SOLVENT; INGEST-NAUSEA,
VOM. EYES-IRRIT. SKIN CONTACT-DERMATITIS. INHALATION-IRRITATION OF
EYE, NOSE, AND THROAT, DIZZINESS. LARGE AMOUNTS IF RETAINED LEAD TO
SYMPTOMS OF CENTRAL NERVOUS DEPRESS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SKIN:DERMATITIS.
INHALATION:EMPHYSEMA.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH LARGE QUANTITIES OF WATER FOR AT LEAST 15
MINUTES, CALL PHYSICIAN. SKIN:REMOVE EXCESS WITH CLOTH OR PAPER.
WASH THOROUGHLY WITH SOAP AND WATER. INHAL:REMOVE VICTIM TO FRESH
AIR, CALL PH YSICIAN. INGEST:SEEK MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:100F,38C
Lower Limits:.8
Upper Limits:6
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATERSPRAY, WATER FOG
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:IF VOLUME IS SIGNIFICANT, TRANSFER INTO
CONTAINERS FOR DISPOSAL. SEAL CONTAINERS. ABSORB WITH AN INERT
INGREDIENT SUCH AS EARTH, SAND OR VERMICULITE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID ALL IGNITION SOURCES SUCH AS
FLAMES AND SPARKS. DO NOT HANDLE OR STORE AT TEMPERAUTRES ABOVE 38C
(100F).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR FOR MIST AND
PARTICULATES.
Ventilation:MECHANICAL RECOMMENED.
Other Protective Equipment:LONG SLEEVED SHIRTS RECOMMENDED.
Work Hygienic Practices:WASH CLOTHES AND SKIN THOROUGHLY.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:350F,177C
Vapor Density:4
Spec Gravity:.970 (H2O=1)
Evaporation Rate & Reference:0.2 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN COLORED LIQUID, MILD SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENT, ACIDS.
Stability Condition to Avoid:STORE AT AMBIENT TEMPERATURES. AVOID
SPARKS AND FLAME. ROTATE STOCK.
Hazardous Decomposition Products:CO AND CO2 FROM BURNING.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AEROSHELL GREASE 22;SHELL CODE:70022
CAGE:54527
CAGE:54527
============= Composition/Information on Ingredients =============
Ingred Name:POLYALPHAOLEFINS
Fraction by Wt: 86%
Ingred Name:ALKYLATED AROMATIC AMINES (ACCD TO MFR:ORAL LD50,RAT >10
G/KG)
Fraction by Wt: 3%
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 0.5%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM NITRITE (SARA III)
CAS:7632-00-0
RTECS #:RA1225000
Fraction by Wt: 0.5%
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:AMITROLE (SARA III)
CAS:61-82-5
RTECS #:XZ3850000
Fraction by Wt: <.05%
OSHA PEL:0.2 MG/M3
ACGIH TLV:0.2 MG/M3; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES AND SKIN;CNS
EFFECTS LIKE HEADACHE,DIZZINESS,NAUSEA,VOMITING;CHRONIC:DRYING OF
SKIN,DEFATTING OR DERMATITIS.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION.
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:455F,235C
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;SCOOP UP AND
CONTAIN FREE MATERIAL IF POSSIBLE;USE SUITABLE INERT ABSORBENT
MATERIAL AND RECOVER FOR PROPER DISPOSAL IN AN APPROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:MFR STATES:THE CONC OF 3-AMINO-1,2,4-TRIAZOLE,SODIUM
NITRITE & SECONDARY AMINES THAT COULD FORM NITROSAMINES IS
LOW.HOWEVER,HANDLING & SAFETY PROCEDURES SHOULD BE STRICTLY
FOLLOWED,MIN EXPOS
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT NEEDED;USE NIOSH/MSHA APPROVED
RESPIRATOR AS REQUIRED IF ABOVE PEL/TLV OR SCBA IN AN ENCLOSED
AREA.
Ventilation:NORMAL ROOM VENTILATION;LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE WASH STATION,WORK CLOTHING AND APRON AS
REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
ADD INGRED:INORGANIC CLAY THICKENER,6%; FATTY AMIDES,3%:DICARBOXYLIC
ACID,1%;MINERAL ACID,0.5% 3-AMINO-1,2,4-TRIAZOLE ORAL
LD50,RAT=14.7G/KG.UNIT OF ISSUE:35LB CONTAINER
================== Physical/Chemical Properties ==================
HCC:V6
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SMOOTH AMBER GREASE.SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:NO*X,CO & OTHER UNIDENT OXYGENATES CAN
FORM DURING COMBUST
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES.DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RUST REFORMER, 7830
CAGE:08882
CAGE:08882
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-BUTOXY-; (DIETHYLENE GLYCOL MONOMETHYL ETHER)
LEL: 1.5% VP: 1 @ 20C
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TANNIC ACID
CAS:1401-55-4
RTECS #:WW5075000
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: HIGH VAPOR
CONCENTRATIONS CAN IRRITATE EYES, NOSE AND RESPIRATORY PASSAGES.
SKIN/EYES: DUE TO LOW PH, PRODUCT IS A SLIGHT TO MODERATE IRRITANT
IN REPEATED CONTACT. INGEST: NON-TOXIC. CHR ONIC: NONE RECOGNIZED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOS. EYES: FLUSH IMMED W/LGE AMTS OF
WATER FOR AT LEAST 15 MIN. NOTIFY PHYSICIAN. SKIN: WASH AFFECTED
AREA W/SOAP & WATER & REMOVE CONTAM CLTHG. IF REDNESS,
ITCHING/BURNING SENSAT ION DEVELOPS CONSULT PHYSICIAN & HAVE THIS
INFORMATION AVAILABLE. INGEST: DO NOT INDUCE VOMIT. DILUTE W/WATER.
IF GI SYMP DEVELOP, CONTACT PHYSICIAN. NEVER GIVE ANYTHING BY MOUTH
TO UNCONSCIOUS PERS.
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WATER MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT BUILD-UP OF STEAM. WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT DUE TO BUILD-UP OF STEAM.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP LIQUID WITH ABSORBENT AND SHOVEL INTO
WASTE CONTAINER. WASH SPILL AREA WITH WATER AND FLUSH TO SEWER
SERVICED BY WASTEWATER TREATMENT FACILITY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NON-FLAMMABLE. SEE OSHA 1910.106. KEEP
FROM FREEZING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE
RESPIRATOR TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY DURING
SPRAY APPLICATION.
Ventilation:PROVIDE GEN DILUTION/LOC EXHAUST VENT IN VOL & PATTERN TO
KEEP TLV OF HAZ INGREDS BELOW ACCEPTABLE LIMITS.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH: 1.3 - 2.3.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Density:HVR/AIR
Spec Gravity:1.258
pH:SUPDAT
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:57
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FLAME: CARBON MONOXIDE AND CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CUT-MAX 206
Preparer's Name:DAVID H. EADLINE
CAGE:HO942
CAGE:HO942
CAGE:73277
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL,PETRO DISTALLATES,HYDROTREATED HEAVY NAPHTHENIC
DISTILLATE;(MINERAL OIL).PEL & TLV 5MG/M3;10MG/M3 STEL(MFR).
CAS:64742-52-5
RTECS #:PY8035000
Fraction by Wt: 10-30%
OSHA PEL:SEE INGREDIENT NAME
ACGIH TLV:SEE INGREDIENT NAME
Ingred Name:MINERAL OIL,PETRO DISTILLATES,SOLV-REFINED HEAVY NAPHTHENIC
DISTILLATE;(MINERAL OIL).PEL & TLV:5MG/M3;10MG/M3 STEL(MFR).
CAS:64741-96-4
RTECS #:PY8040000
Fraction by Wt: 10-30%
OSHA PEL:SEE INGREDIENT NAME
ACGIH TLV:SEE INGREDIENT NAME
Ingred Name:GAS OIL, BLEND; (MINERAL OIL), PEL & TLV: 5 MG/M3;10 MG/M3
STEL (MFR).
CAS:64741-44-2
RTECS #:LX3296000
Fraction by Wt: >60%
OSHA PEL:SEE INGREDIENT NAME
ACGIH TLV:SEE INGREDIENT NAME
Ingred Name:DISTILLATES (PETROLEUM), HYDROTREATED MIDDLE; (MINERAL
OIL), PEL & TLV: 5 MG/M3; 10 MG/M3 STEL (MFR).
CAS:64742-46-7
RTECS #:JN9379645
Fraction by Wt: >60%
OSHA PEL:SEE INGREDIENT NAME
ACGIH TLV:SEE INGREDIENT NAME
Ingred Name:MINERAL OIL, PETRO DISTILLATES, HYDROTREATED LIGHT
NAPHTHENIC; (MINERAL OIL), PEL & TLV: 5 MG/M3; 10 MG/M3 STEL (MFR).
CAS:64742-53-6
RTECS #:PY8036000
Fraction by Wt: >60%
OSHA PEL:SEE INGREDIENT NAME
ACGIH TLV:SEE INGREDIENT NAME
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: AVOID BRTHG PROD MISTS.
BRTHG MISTS IN EXCESS OF TLV MAY CAUSE IRRIT OF UPPER RESP TRACT.
PERSONS WITH CHRONIC RESP DISEASE MAY SHOW INCREASED SYMP DUE TO
IRRIT. SKIN: MAY BE MILD IRRITA NT ON PRLNGD CONTACT. PERSONS
W/PRE-EXISTING SKIN DISORDERS MAY BE MORE SUSCEPTIBLE TO EFTS OF
(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:RTECS LIST CAS NOS.64742-52-5 AND
64741-96-4 AS GROUP 1 CARCINOGENS.
Effects of Overexposure:HLTH HAZ:OIL MISTS IF CREATED DURING PROD USE.
EYE: MINERAL OIL MIST IS NOT KNOWN TO BE AN EYE IRRITANT: NEAT
PRODUCT IS A MODERATE IRRITANT. INGEST: NO SIGNIFICANT EFFECTS
KNOWN. CHRONIC: UNKNOWN FOR THIS PRODUCT.
Medical Cond Aggravated by Exposure:PERSONS WITH CHRONIC RESPIRATORY
DISEASE MAY SHOW INCREASED SYMPTOMS DUE TO IRRITATION.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO SOURCE OF FRESH AIR. SKIN: WASH WITH SOAP
AND WATER. EYE: FLUSH WITH WATER FOR AT LEAST 15 MINUTES; CONSULT
PHYSICIAN. INGEST: DO NOT INDUCE VOMITING. GIVE LIQUIDS, CONSULT
PHYSICIAN.PRODUCT IS MAINLY MINERAL OIL.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:295F,146C
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . TREAT AS OIL FIRE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:APPLY DRY OIL ABSORBENT TYPE MATERIAL AND
SWEEP UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH STRONG OXIDIZERS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR REQUIRED ONLY IF
TLV FOR OIL MIST IS EXCEEDED.
Ventilation:EXHAUST TYPE IF MISTING; OTHERWISE GENERAL TYPE IS
SATISFACTORY.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:518F,270C
Vapor Pres:<0.01
Vapor Density:8.6
Spec Gravity:0.86
Evaporation Rate & Reference:<0.1
Solubility in Water:INSOLUBLE.
Appearance and Odor:DARK AMBER FLUID; SLIGHT ODOR OF SULFURIZED OIL.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL; OXIDES OF CARBON AND SULFUR.
TRACE HYDROGEN CHLORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE, AND LOCAL
REGULATIONS FOR DISPOSAL OF WASTE PETROLEUM OIL. MAY BE INCINERATED
UNDER CONTROLLED CONDITIONS. NOT CONSIDERED A POLLUTANT IF
EFFECTIVE WASTE DISP METHS ARE UTILIZED. KEEP OUT OF SEWERS &
STREAMS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KERMEED
CAGE:HO033
CAGE:22402
CAGE:HO033
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 14%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:MAY CAUSE IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINS & GET MD AS SOON AS
POSSIBLE. SKIN: FLUSH THOROUGHLY W/WATER.
===================== Fire Fighting Measures =====================
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:RETURN UNCONTAMINATED PORTION TO CONTAINER
W/METAL SCOOP OR SHOVEL. SWEEP UP REMAINDER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
DO NOT TAKE INTERNALLY.
Other Precautions:WHEN MAKING SOLUTIONS, ADD COMPOUND CAREFULLY TO
AVOID VIOLENT SPATTERING OR SPLASHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MFR RECOMNDS NONE
Other Protective Equipment:RUBBER BOOTS, IF STANDING IN RUN-OFF.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:APPRECIABLE
Appearance and Odor:YELLOW GRANULAR MATERIAL, MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM, STRONG ACIDS.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FED, ST & LOCAL REGS FOR ALKALINE
MATERIALS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A76020P, STRIPPER FOR POSITIVE WORKING PHOTO (SUPDAT)
CAGE:91345
CAGE:91345
============= Composition/Information on Ingredients =============
Ingred Name:CARBONIC ACID, CYCLIC PROPYLENE ESTER; (PROPYLENE
CARBONATE)
CAS:108-32-7
RTECS #:FF9650000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPANOL, 3-(3-(3-METHOXYPROPOXY)PROPOXY)-; (TRIPROPYLENE
GLYCOL METHYL ETHER)
CAS:10213-77-1
RTECS #:UB8050000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:CONTACT WITH EYES MAY CAUSE
IRRITATION AND REDNESS. REPEATED AND PROLONGED EXPOSURE TO THE SKIN
MAY RESULT IN THE MATERIAL BEING ABSORBED IN HARMFUL AMOUNTS.
SINGLE DOSE ORAL TOXICITY IS LOW. SW ALLOWING LARGE AMOUNTS CAN
CAUSE INJURY. INHALATION NOT LIKELY TO CAUSE INJURY. CHRONIC:NONE
KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:IF CONDITIONS PERSIST, GET MEDICAL ATTENTION. EYES:IF EYE
CONTACT OCCURS, FLUSH WITH WATER FOR AT LEAST 15 MINUTES OR UNTIL
IRRITATION SUBSIDES. IF IRRITATION PERSISTS, CALL DOCTOR. SKIN:IN
CASE OF SK IN CONTACT, REMOVE ANY CONTAMINATED CLOTHING AND WASH
SKIN THORO WITH SOAP & WATER. INHAL:IF OVERCOME BY VAP/MIST, REMOVE
FROM EXPOSED AREA & CALL MD IMMED. INGEST:DO NOT INDUCE VOMIT; CALL
MD IMMED.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:FOAM, WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF AND ELIMINATE ALL IGNITABLE SOURCES.
CONTAIN AND COLLECT MATERIAL. ABSORB RESIDUE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE AND STORE AWAY FROM HEAT, SPARKS
AND OPEN FLAME. KEEP CONTAINERS SEALED WHEN NOT IN USE.
Other Precautions:KEEP ALL CHEMICALS OUT OF THE REACH OF CHILDREN. KEEP
CONTAINER CLOSED. DO NOT USE OR STORE NEAR HEAT OR FLAME. READ AND
UNDERSTAND ALL CAUTIONS, LABELS AND MSDS BEFORE USING THIS PRODUCT.
MIN BRTHG V AP/MIST. AVOID PRLNGD/RPTD CONT W/SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE NORMALLY REQUIRED.
Ventilation:USE MECHANICAL DILUTION VENT WHENEVER PROD IS USED IN A
CONFINED SPACE, IS HEATED ABOVE AMBIENT TEMPS/IS AGITATED.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
MFR TRADE/PART NAME:ETCH ALUMINUM/STAINLESS STEEL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:462F,239C
Vapor Pres:<0.03@25C
Spec Gravity:1.08 (H*2O=1)
Solubility in Water:100% (H*2O)
Appearance and Odor:CLEAR WITH MILD ETHER ODOR.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG ACIDS AND STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO*X, NO*X AND HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT FEDERAL, STATE, COUNTY OR LOCAL
ENVIRONMENTAL REGULATORY AGENCIES FOR GUIDANCE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CREAM HARDENER TUBED 27642 GREEN
CAGE:UO401
CAGE:UO401
============= Composition/Information on Ingredients =============
Ingred Name:BENZOYL PEROXIDE
CAS:94-36-0
RTECS #:DM8575000
Minumum % Wt:47.5
Maxumum % Wt:50.
ACGIH TLV:5 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:EYES: CONTACT WITH EYES CAN CAUSE IRRITATION,
REDNESS, TEARING, BLURRED VISION, AND/OR SWELLING.SKIN: CONTACT
WITH SKIN CAN CAUSE IRRITATION, (MINOR ITCHING, BURNING AND/OR
REDNESS), DERMATITIS, DEF ATTING MAY BE READILY ABSORBED THROUGH
THE SKIN. INHALATION: INHALATION OF VAPORS CAN CAUSE NASAL AND
RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA,
HEADACHE, POSSIBLE UNCONSCIOUSNESSAND/OR ASPHYXIATION.
ASPIRATION OF MATERIAL INTO LUNGS MAY RESULT IN CHEMICAL
PNEUMONITIS WHICH CAN BE FATAL. INGESTION: CAN CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALATION: IF INHALED, REMOVE VICTIM FROM EXPOSURE TO A
WELL-VENTILATED AREA. MAKE THEM COMFORTABLY WARM, BUT NOT HOT.
USE OXYGEN OR ARTIFICIAL RESPIRATION AS REQUIRED. SKIN: FOR SKIN
CONTACT, WAS H PROMPTLY WITH SOAP AND EXCESS WATER. EYES: FOR EYE
CONTACT, FLUSH PROMPTLY WITH EXCESS WATER FOR AT LEAST 15 MINUTES.
INGESTION: IF INGESTED, DO NOT INDUCE VOMITING. GIVE VICTIM A
GLASS OF WATER. IN ALL CASES, SEEK IMMEDIATE MEDICAL ATTENTION!
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:=84.4C, 184.F
Lower Limits:N/E
Upper Limits:N/E
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FIGHT LIKE A FUEL OIL FIRE. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. FIREFIGHTER SHOULD WEAR OSHA/NIOSH
APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO HIGH
TEMPERATURES, SUCH AS FIRE CONDITIONS MAY RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE ALL POSSIBLE SOURCES
OF IGNITION. AVOID PROLONGED BREATHING OF VAPOR. CONTAIN SPILL
WITH INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. AVOID
CONTACT WITH EYES AND SKIN. AVOID BREATHING VAPORS. DO NOT STORE
THE PRODUCT ABOVE 100F. DO NOT FLAME, CUT, BRAZE WELD OR MELT
EMPTY CONTAINERS. KEEP THE PROD UCT AWAY ROM HEAT, OPEN FLAME, AND
OTHER SOURCES OF IGNITION.AVOID CONTACT WITH STRONG ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF COMPONENT TLV LIMITS ARE EXCEEDED, USE
NIOSH/MSHA APPROVED RESPIRATOR TO REMOVE VAPORS. USE AN
AIR-SUPPLIED RESPIRATOR IF NECESSARY.
Ventilation:USE ADEQUATE VENTILATION IN VOLUME AND PATTERN TO KEEP
TLV/PEL BELOW RECOMMENDED LEVELS. EXPLOSION-PROOF VENTILATION MAY
BE NECESSARY.
SHIELDS
Other Protective Equipment:WEAR PROTECTIVE CLOTHING AS REQUIRED TO
PREVENT SKIN CONTACT.
Supplemental Safety and Health
VOLATILES BY WEIGHT 10-20%. HMIS RATINGS: HEALTH=2, FIRE=2,
REACTIVITY=2.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Vapor Pres:N/E
Vapor Density:>AIR
Spec Gravity:1.20
Evaporation Rate & Reference:<1(ETHER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:GREEN PASTE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ALKALIES, OXIDIZERS.
Stability Condition to Avoid:OPEN FLAMES, SPARKS, HEAT, ELECTRICAL AND
STATIC DISCHARGE.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE, AND
CARBON.
=================== Toxicological Information===================
Toxicological Information:BENZOYL PEROXIDE HAS CAUSED TUMORGENIC
EFFECTS IN LABORATORY ANIMALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
===================== Regulatory Information =====================
SARA Title III Information:THIS PRODUCT CONTAINS THE FOLLOWING TOXIC
CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF THE EMERGENCY
PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1986 AND 40 CFR 372:
BENZOYL PEROXIDE.
State Regulatory Information:CALIFORNIA PROPOSITION 65: TRACE AMOUNTS
OF SOME CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER,
BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM MAY BE PRESENT IN THIS
PRODUCT.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:965 FLOORING & TREAD ADHESIVE
CAGE:1CCC0
CAGE:1CCC0
============= Composition/Information on Ingredients =============
Ingred Name:NOT HAZARDOUS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: MAY CAUSE SLIGHT
IRRITATION. SKIN CONTACT: NO EFFECT KNOWN. INGESTION: NOT LIKELY
TO OCCUR. IF SWALLOWED, NO SIDE EFFECTS KNOWN. INHALATION: NO
EFFECT KNOWN. CHRONIC: NONE KNOWN.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH WITH WATER FOR 15 MINUTES. CONTACT A
PHYSICIAN IF IRRITATION OCCURS. SKIN CONTACT: WASH WITH SOAP AND
WATER. INGESTION: INDUCE VOMITING, CONTACT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:WATER FOG, CO2, DRY CHEMICAL, AND CHEMICAL FOAM.
Fire Fighting Procedures:USE PROTECTIVE CLOTHING AND SELF-CONTAINED
BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:DISPENSE SAND, SAWDUST, OR VERMICULITE.
COLLECT AND PLACE IN WASTE CONTAINER. WASH AREA THOROUGHLY WITH
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF THE REACH OF CHILDREN.
STORE ABOVE 40 F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED WITH GOOD VENTILATION.
Ventilation:NORMAL ROOM VENTILATION.
Work Hygienic Practices:USE GOOD HYGIENIC PRACTICES. WASH HANDS BEFORE
EATING, USING WASHROOM, OR SMOKING.
Supplemental Safety and Health
VOC = 0 G/L
================== Physical/Chemical Properties ==================
Boiling Pt:=100.C, 212.F
Vapor Pres:SAME AS WATER
Vapor Density:AS WATER
Spec Gravity:1.1
pH:9.5
Appearance and Odor:WHITE COLORED PASTE WITH LITTLE OR NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LITHIUM COMPLEX GREASE, 16005
CAGE:HO995
CAGE:HO995
CAGE:98148
============= Composition/Information on Ingredients =============
Ingred Name:LITHIUM 12-HYDROXYOCTADECANOATE; (LITHIUM 12
HYDROXYOCTADECANOATE SEBACATE)
CAS:68815-49-6
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED
(SEVERE), HEAVY PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038501
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SULFURIZED ISOBUTYLENE
CAS:68511-50-2
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:DIFFICULTY IN
BREATHING. SKIN:REDNESS. INGESTION:VOMITING. MAY CAUSE DIZZINESS OR
NACOSIS IN HIGH VAPOR CONCENTRATIONS. WILL CAUSE DEFATTING OF SKIN.
EFFECTS ARE REVERSIBLE. LONG TERM EXPOSURE (YEARS) VAPOR MAY CAUSE
LUNG,LIVER OR KIDNEY DAMAGE. THE SOLVENTS LISTED HAVE BEEN (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:REPORTED TO AFFECT CENTRAL NERVOUS
SYSTEM.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INCUDE VOMITING; GET MEDICAL ATTENTION.
SKIN:WASH WITH SOAP AND WATER. EYES:FLUSH WITH FRESH WATER FOR @
LEAST 15 MINUTES. INHAL:REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:440F,227C
Extinguishing Media:WATER FOG, DRY CHEMICAL, FOAM, EARTH OR SAND.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY CAUSE FROTHING.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH SAND OR INERT MATERIAL AND PLACE
IN CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SPARKS AND OPEN FLAMES.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQD WITH ADEQUATE VENTILATION. NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:APRON AS REQUIRED.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
SPEC GRAV:0.89 @ 16C (H*20=1).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:700F,371C
Melt/Freeze Pt:M.P/F.P Text:500F,260C
Vapor Pres:<0.01
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:<0.1 (BUTYL ACETATE =1)
Solubility in Water:NIL
Appearance and Odor:AMBER SEMI-SOLID/BLAND
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE IF
INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:75-1663-840 TONER FOR LASER PRINTERS UNISYS
CAGE:KYOCE
CAGE:S7506
CAGE:KYOCE
CAGE:2J705
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE/N-BUTYL ACRYLATE COPOLYMER
Other REC Limits:NONE RECOMMENDED
Ingred Name:MAGNETITE (FE3O4), IRON OXIDE
CAS:1317-61-9
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 TOT. PART.
ACGIH TLV:5 MG/M3 (FE) FUME
Ingred Name:POLYPROPYLENE WAX
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 NUISANCE
ACGIH TLV:10 MG/M3 NUISANCE
Ingred Name:SILICA, AMORPHOUS, DIATOMACEOUS EARTH, CONTAINING LESS THAN
1% CRYSTALLINE SILICA
CAS:61790-53-2
RTECS #:HL8600000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:20 MPPCF
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAN IRRITATE AND/OR BURN EYES
AND SKIN. CAN DAMAGE RESPIRATORY AND DIGESTIVE SYSTMEMS. CHRONIC:
NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:EYES/SKIN: IRRITATION, BURNS. INHALATION:
IRRITATION OF NOSE AND THROAT, COUGHING. INGESTION: UPSET STOMACH.
Medical Cond Aggravated by Exposure:CAN AGGRAVATE EXISTING EYE, SKIN,
RESPIRATORY AND DIGESTIVE SYSTEM CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR 15 MINUTES, LIFTING
UPPER AND LOWER LIDS OCCASIONALLY. SEE DOCTOR IMMEDIATELY. SKIN:
WASH WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. GIVE
CPR/OXYGEN IF NEEDED. SEE DOCTOR. INGESTION: GIVE 2 LARGE GLASSES
OF WATER. INDUCE VOMITING. SEE DOCTOR.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS. DUST MAY CAUSE
EXPLOSIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE. CLEAN UP USING METHODS THAT AVOID
DUST GENERATION SUCH AS VACUUM, WET DUST MOP OR WET CLEAN UP AND
PLACE IN APPROPIATE DISPOSAL CONTAINER AND COVER. IF DUST IS
GENERATED USE NIOSH/MSHA APPR OVED RESPIRATOR WITH DUST CARTRIDGE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. USE DUST RESPIRATOR IN
CASE OF A SPILL.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:EYE WASH STATION.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
SOLUTION SPILL: ABSORB IN INERT INGREDIENT AND PLACE IN APPROPIATE
DISPOSAL CONTAINER. WATER SOLUTIONS ARE SLIPPERY. WASH AREA WITH
SOAP AND WATER. WATER SOLUTION IS BIODEGRADABLE.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:284F,140C
Spec Gravity:1.5
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER. ALMOST NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:NOTIFY YOUR LOCAL ENVIRONMENTAL OFFICER. KEEP IN
COVERED CONTAINERS PENDING DISPOSAL. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TURCO FLURO CHEK NAD DEVELOPER
CAGE:D9808
CAGE:61102
CAGE:D9808
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 90%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
===================== Hazards Identification =====================
Effects of Overexposure:IRRITATION OF EYES,NOSE & THROAT.
======================= First Aid Measures =======================
First Aid:REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:60F/15.6C(TCC)
Lower Limits:2.5%
Upper Limits:U/K
Extinguishing Media:CARBON DIOXIDE,CHEMICAL FOAM
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:AS FOR FLAMMABLE LIQUID.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:MECHANICAL (GENERAL/LOCAL EXHAUST)
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=82.2C, 180.F
Vapor Pres:33
Vapor Density:>1
Spec Gravity:0.9
Evaporation Rate & Reference:2.3 BUTYL ACETATE
Solubility in Water:MISCIBLE
Appearance and Odor:WHITE OPAQUE LIQUID SUSPENSION,ALCOHOL ODOR
Percent Volatiles by Volume:80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZERS.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:FILTER AND DILUTE AS NECESSARY TO MEET
UNDISSOLVED SOLIDS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:ROYCO 27 A
CAGE:07950
CAGE:66172
CAGE:07950
============= Composition/Information on Ingredients =============
Ingred Name:ADIPIC ACID; DIISOOCTYL ESTER - SYNTHETIC ESTER
CAS:1330-86-5
Fraction by Wt: 70 - 80%
Other REC Limits:NONE SPECIFIED
Ingred Name:LITHIUM 12 HYDROXYSTEARATE
CAS:7620-77-1
Fraction by Wt: 10 - 20%
Other REC Limits:NONE SPECIFIED
Ingred Name:ANTIMONY DIALKYLDITHIOCARBAMATE
CAS:15991-76-1
Fraction by Wt: 0 - 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG SB/M3
ACGIH TLV:0.5 MG SB/M3
Ingred Name:ADDITIVE CONTAINING POLYISOBUTYLENE
Fraction by Wt: 0 - 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:MINOR ADDITIVES
Fraction by Wt: <4%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT AVAILABLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYES:MILD
IRRITATION.SKIN:PROLONGED/REPEATED CONTACT MAY CAUSE
DERMATITIS,FOLLICULITIS/OIL ACNE.INHALATION:AT HIGH
TEMPERATURES,VAPORS MAY CAUSE NOSE,THROAT & UPPER RESPIRATORY TRACT
IRRITATION. INGESTION:LOW ORDER OF TOXICITY.CHRONIC:NONE GIVEN.
Effects of Overexposure:SEE HEALTH HAZARDS SECTION.
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY DISORDERS
MAY BE AGGRAVATED BY EXPOSURE TO LITHIUM HYDROXYSTEARATE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION.INHALATION:REMOVE TO FRESH AIR.GIVE
OXYGEN IF NEEDED.INGESTION:DO NOT INDUCE VOMITING.NO TREATMENT IS
NECESSARY UNLESS LARGE AMOUNT OF PRODUCT IS INGESTED.EYE:FLUSH WITH
WATER FO R 15 MINUTES WHILE HOLDING EYELIDS OPEN.SKIN:WIPE EXCESS
OFF.FLUSH WITH WATER.FOLLOW WASHING WITH SOAP & WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:400F,204C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, DRY CHEMICAL.DO NOT
USE A DIRECT STREAM OF WATER.PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:WATER SPRAY MAY BE USEFUL IN CONTAINERS
EXPOSED TO FLAMES.DO NOT ENTER CONFINED FIRE SPACE WITHOUT PROPER
PROTECTIVE EQUIPMENT INCLUDING NIOSH APPROVED SCBA.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS:TAKE UP WITH AN ABSORBENT
MATERIAL.LARGE SPILLS:WEAR RESPIRATORY EQUIPMENT PROTECTIVE
CLOTHING.SHUT OFF SOURCE OF LEAK IF SAFE TO DO SO.DIKE &
CONTAIN.REMOVE WITH VACUUMS OR PUMP TO STORA GE/SALVAGE
VESSELS.FLUSH TRACES WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,VENTILATED
PLACE.KEEP AWAY FROM OPEN FLAMES & HIGH TEMPERATURES.
Other Precautions:WASH WITH SOAP & WATER BEFORE EATING, DRINKING,
SMOKING OR USING TOILET FACILITIES. LAUNDER CONTAMINATED CLOTHING
BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE EITHER AN ATMOSPHERE-SUPPLYING RESPIRATOR OR
AN AIR-PURIFYING RESPIRATOR FOR ORGANIC VAPORS.USE A NIOSH-APPROVED
RESPIRATOR AS REQUIRED TO PREVENT OVEREXPOSURE.
Ventilation:WORK IN A WELL VENTILATED AREA.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATIONS, SEE PNI A AND B, SAME NSN.
================== Physical/Chemical Properties ==================
HCC:V6
NRC/State Lic Num:NOT RELEVANT
Spec Gravity:APPROX. <1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER LIQUID WITH MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:AVOID HEAT AND OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE,OXIDES OF
ANTIMONY,SULFUR,LITHIUM,NITROGEN AND OTHER UNIDENTIFIED ORGANIC
COMPOUNDS
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN AN APPROPRIATE DISPOSAL FACILITY IN
COMPLIANCE WITH LOCAL REGULATIONS.UNDER EPA-CWA,THIS PRODUCT IS
CONSIDERED AN OIL UNDER SECTION 311.SPILLS INTO SURFACE WATERS THAT
CAUSE A SHEEN MUST BE R EPORTED TO THE NATIONAL RESPONSE
CENTER8004248802
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EXTERIOR ACRYLIC LATEX PRIMER, 06438/6-438
CAGE:0EKH6
CAGE:0EKH6
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA) VP:0.05
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5.0%
OSHA PEL:N/K
ACGIH TLV:C 50 PPM,VAPOR
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:VAPORS OR SPRAY MISTS MAY
BE IRRITATING TO EYES, NOSE, THROAT AND MUCOUS MEMBRANES OF THE
RESPIRATORY TRACT PRODUCING SYMPTOMS OF HEADACHE AND/OR NAUSEA IN
POORLY VENTILATED AREAS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SKIN CONTACT:PROLONGED OR CONTACT
WITH COATING MAY CAUSE SKIN IRRITATION. EYE CONTACT:DIRECT EYE
CONTACT WILL CAUSE EYE IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
O*2/ARTIFICIAL RESPIRATION) . SKIN:WASH WITH SOAP AND WATER.
EYE:IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES; CONS ULT A PHYSICIAN. INGESTION:IF VICTIM ISCONSCIOUS,
GIVE 2 GLASSES OF WATER AND CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . NONE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL AND REMOVE WITH INERT MATERIAL
(SAND, EARTH, ABSORBENT). KEEP SPILL OUT OF SEWERS AND OPEN BODIES
OF WATER. KEEP UNNECESSARY PEOPLE AWAY, AS FLOOR MAY BE SLIPPERY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE ABOVE 34F AND BELOW 140F. DO NOT
TAKE INTERNALLY.
Other Precautions:THIS COATING CNTNS MATLS CLASSIFIED AS NUISANCE
PARTICULATES, FOR EXAMPLE TITANIUM DIOXIDE, CALCIUM CARBONATE, ETC.
(SEE ACGIH TLV LIST, PREFACE & APPENDIX D) WHICH MAY BE PRESENT AT
HAZ LEVELS ONLY D URING SPRAYING THIS COATING OR (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED
EXCEPT IF PRODUCT IS SPRAYED, THEN USE MASK (NIOSH/MSHA APPROVED).
IF TLV IS EXCEEDED THEN USE CANNISTER OR AIR HOSE MASK.
Ventilation:MECHANICAL-LOCAL EXHAUST AT POINT OF CONTAMINANT RELEASE
(VAPOR, MIST OR DUST).
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER .
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING BATHROOM.
Supplemental Safety and Health
OTHER PRECS:SANDING OR ABRADING OF THE DRIED FILM.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE ING 1
Vapor Density:LTR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ANY MATERIAL THAT REACTS VIOLENTLY WITH WATER.
Stability Condition to Avoid:FREEZING OR TEMPERATURE OVER 140F.
Hazardous Decomposition Products:ACETIC ACID, CO AND CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PARSONS' CLEAR DETERGENT AMMONIA
CAGE:5B765
CAGE:5B765
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIA (CLEAR DETERGENT)
CAS:7664-41-7
RTECS #:BO0875000
Fraction by Wt: <4%
OSHA PEL:35 PPM STEL
ACGIH TLV:25 PPM, 35 STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:WARNING SIGNALS:EYE IRRIT WITH
LACRIMATION; NOSE, THROAT, AND CHEST IRRIT. EFTS OF
OVEREXP:INHAL:INFLAMM, IRRIT OF RESP ORGANS. INGEST:MAY BE HARMFUL
IF SWALLOWED. SKIN/EYES:IRRITATING. LUNGS:IRRITATI NG TO MUCOUS
MEMBRANES.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. GET MED ATTN.
SKIN:FLOOD WITH WATER, WASH WITH VINEGAR. INHAL:REMOVE VICTIM TO
FRESH AIR. INGEST:ADMINISTER WATER OR MILK IMMEDIATELY, GET MED
ATTN. DO N OT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-FLAMMABLE. MEDIA SUITABLE FOR SURROUNDING FIRE
.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:SEE NORMAL CLEAN-UP PROCEDURES. VENTILATE
AREA. FLUSH AWAY SPILLED PRODUCT WITH WATER WHEN VAPORS WILL
PERMIT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT MIX W/OTHER HOUSEHOLD CHEMS
SUCH AS AUTOMATIC TOILET BOWL, WALL OR TILE CLEANERS. PLASTIC
BOTTLE WILL BULGE FROM AMMONIA VAPOR PRESSURE.
Other Precautions:AVOID OVERHEATING. MANUFACTURE IN WELL-VENTILATED,
CLEAN, SAFE AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR THAT WILL PROVIDE
PROTECTION FROM AMMONIA GAS.
Ventilation:USE LOCAL EXHAUST SYSTEM. SAFETY SHOWERS SHOULD BE READILY
AVAILABLE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>191F,>88C
Spec Gravity:0.9890
pH:11.8
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR-PALE BLUE CLEAR LIQUID WITH AMMONIA ODOR
Percent Volatiles by Volume:98.1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHLORINE, BROMINE, IODINE, HYPOCHLORITE, MINERAL ACIDS.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUTE WITH WATER AND FLUSH AWAY. DISPOSE OF IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & IRON OVERALL
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COATING, POLYURETHANE 47 BLK 37030 ID754203
Preparer's Name:W.A. ELLISON
CAGE:FO127
CAGE:FO127
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:PROPYLENE GLYCOL METHYL ETHER ACETATE (VP MM HG @ 20 DEG C
2)
CAS:108-65-6
RTECS #:AI8925000
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:SILICA, AMORPHOUS, DIATOMACEOUS EARTH, CONTAINING LESS THAN
1% CRYSTALLINE SILICA
CAS:61790-53-2
RTECS #:HL8600000
OSHA PEL:20 MPPCF
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:VOL ORGANIC CMPD 4.5 LB/GL LESS WATER & NPRS* 540 G/L LESS
WATER VOC 11.7 LB/GAL SOLIDS 1404 G/L SOLIDS CALCULATED
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:SWALLOWING-GASTROINTESTINAL
IRRITATION, ASPIRATION OF MATERIAL INTO LUNG MAY CAUSE CHEMICAL
PNEUMONITIS. EYE AND SKIN IRRITATION.HIGH CONCENTRATIONS MAY CAUSE
ACUTE CENTRAL NERVOUS SYSTEM DEPRESSION C HARACTERIZED BY
HEADACHE,DIZZINESS,NAUSEA AND CONFUSION.
Effects of Overexposure:REPEATED EXPOSURE TO CRYSTALLINE MAY CAUSE LUNG
DISEASE. (PNEMOCONIOSIS) OVEREXPOSURE TO TOLUENE MAY CAUSE LIVER
DAMAGE. OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN/NERVOUS
SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY CONDITIONS
MAY BE AGGRAVATED BY EXPOSURE TO CRYSTALLINE SILICA.
======================= First Aid Measures =======================
First Aid:SWALLOWING-DO NOT INDUCE VOMITING. GET MED ATTN.
INHALATION-REMOVE TO FRESH AIR AND GET MED ATTN. EYE-FLUSH WITH
WATER FOR 15 MIN. GET MED ATTN. SKIN-REMOVE CONTAMINATED
CLOTHING.WASH AFFECTED AREA IF IRRITATION PERSISTS GET MED ATTN.
NOTETO PHYSICIAN-ANY TREATMENT THAT MIGHT BE REQUIRED FOR
OVEREXPOSURE SHOULD BE DIRECTED TO THE CONTROL OF SYMPTOMS AND THE
CLINICAL CONDITIONS.
===================== Fire Fighting Measures =====================
Flash Point:24F/-4.44C
Extinguishing Media:USE CLASS B FIRE EXTINGUISHERS. POLYMER FOAM IS
PREFERRED FOR LARGE FIRES.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS. USE
WATER TO COOL EXPOSED CONTAINERS TO PREVENT POSSIBLE AUTO
IGNITION/EXPLOSION. USE FOG NOZZLES IF WATER IS USED.
Unusual Fire/Explosion Hazard:OVEREXPOSURE TO DECOMPOSITION MAY CAUSE
HEALTH HAZARD. SYMPTOMS MAY NOT BE IMMEDIATELY APPARENT. OBTAIN
MEDICAL ATTENTION. WARNING: FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. DIKE AND
CONTAIN SPILL WITH INERT MATERIAL. RECOVERY OR DISPOSAL IN A
COVERED METAL CONTAINER. USE NON-SPARKING TOOLS.PREVENT
CONTAMINATION OF SEWERS, STREAMS, GROUNDWA TER.
Neutralizing Agent:NONE LISTED.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 95F.STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29CFR1910.106.
Other Precautions:DO NOT TAKE INTERNALLY.CLOSE CONTAINER AFTER EACH
USE. DO NOT BREATH SANDING DUST. DO NOT RE-USE CONTAINER. DO NOT
WELD/BRAZE OR CUT ON EMPTY CONTAINER. NEVER USE PRESSURE TO EMPTY.
CONT GROUNDED AND BONDED TO THE RECEIVING CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORS RECOMMENDED WITH THIS PRODUCT DURING
AND AFTER THE ADDITION OF CATALYST. PROPERLY FITTED POSITIVE
PRESSURE (TC 19C NIOSH/MSHA) WHILE EXPOSED. IF NOT AVAILABLE USE
VAPOR PARTICULATE, THAT I S EFFECTIVE FOR ISOCYANATE VAPORS AND
Ventilation:GENERAL DILUTION AND LOCAL EXHAUST VENT IN SUFFICIENT
VOLUME & PATTERN TO MAINTAIN CONCENTRATIONS OF HAZARDOUS SUBSTANCE
Other Protective Equipment:NOT LIKELY TO BE NEEDED.
Work Hygienic Practices:NONE LISTED.
Supplemental Safety and Health
RESPIRATORY PROTECTION: MISTS. WEAR RESPIRATOR FOR THE WHOLE TIME WHILE
MIX SPRAYING AND UNTIL VAPORS AND MISTS ARE GONE. THIS URETHANE
BASE IS ONE PART OF A TWO COMPONENT MIXTURE. INTENDED TO BE MIXE D
WITH AN ACTIVATOR. THE CONTENTS OF THIS PKG MUST BE BLENDED WITH
OTHER COMPONENTS BEFORE THE PRODUCT CAN BE USED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175F/281F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:61
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING/WELDING/CUTTING WILL PRODUCE
SMOKE,CARBON MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT,SPARKS AND
FLAME.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FED/ST/LOCAL LAWS.INCINERATE ONLY IN
EPA FACILITY. DISPOSE IN A HAZARDOUS WASTE LANDFILL. RCRA
CLASSIFICATION WOULD BE D001. ENVIRONMENTAL HAZARDS NONE KNOWN.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & STEEL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SONICBRITE 300 (5 GAL)
CAGE:63067
CAGE:63067
============= Composition/Information on Ingredients =============
Ingred Name:WATER, H2O
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >70%
Ingred Name:POTASSIUM PHOSPHATE TRIBASIC, TRIPOTASSIUM PHOSPHATE
CAS:7778-53-2
Fraction by Wt: <30%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION & CONJUNCTIVITIS.
SKIN: IRRITATION. INGESTION: IRRITATION TO MOUTH,
THROAT/GASTROINTESTINAL TRACT, NAUSEA, VOMITING & BURNS TO THE
ESOPHAGUS. INHALATION: IRRITATION TO NOSE & THROAT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION & CONJUNCTIVITIS. SKIN:
IRRITATION. INGESTION: IRRITATION TO MOUTH, THROAT,
GASTROINTESTINAL TRACT, NAUSEA, VOMITING & BURNS TO THE ESOPHAGUS.
INHALATION: IRRITATION TO NOSE & THROAT.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER. SKIN: WASH EXPOSED AREA
W/WATER. INGESTION: DRINK 2 TO 3 GLASSES OF WATER OR MILK. DON'T
NEUTRALIZE W/ACID. HEAT OF NEUTRALIZATION MAY SEPERATE HEAT THAT
MAY RESU LT IN PERFORATION. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE W/WEAK ACID. DILUTE W/LARGE AMOUNTS
OF WATER (1 + 10 RATIO). SEWER DISPOSAL MAY BE SUITABLE UNDER AN
APPROVED PERMIT.
Neutralizing Agent:WEAK ACID
======================Handling and Storage ======================
Handling and Storage Precautions:STORE THIS PRODUCT AT ROOM
TEMPERATURE.
Other Precautions:CONTACT LENS USERS SHOULD WEAR REGULAR GLASSES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:MECHANICAL/LOCAL EXHAUST RECOMMENDED
Other Protective Equipment:LAB COAT
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Spec Gravity:1.22
pH:12.5
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS ODORLESS SOLUTION.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL REGULATORY AGENCIES FOR
APPROPRIATE WASTE DISPOSAL METHODS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PAPER MATE OFFICE PRODUCTS CORRECTION (SUPP
CAGE:9A977
CAGE:9A977
CAGE:26333
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA PETROLEUM, HEAVY ALKYLATE C*9-C*12; (MINERAL
SPIRITS). PEL AND TLV AS VM&P NAPHTHA
CAS:64741-65-7
OSHA PEL:300 PPM;400 PPM STEL
ACGIH TLV:300 PPM
Ingred Name:DI-SEC-OCTYL PHTHALATE (DI-2-ETHYLHEXYL-PHTHALATE)(SARA
III)
CAS:117-81-7
RTECS #:TI0350000
OSHA PEL:5 MG/M3/10 STEL
ACGIH TLV:5 MG/M3; 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ISOTHIOCYANIC ACID, ALLYL ESTER; (MUSTARD OIL)
CAS:57-06-7
RTECS #:NX8225000
Ingred Name:COLORANTS
Ingred Name:SUPP DATA: HUMANS. ADRENOMIMETICS (E.G., EPINEPHRINE) MAY
BE CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: HUMANS ACUTELY OR CHRONICALLY EXPOSED TO
CHLOROCARBONS .
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: OF THE MD. DO NOT USE SYMPATHOMIMETIC
AGENTS (E.G., EPINEPHRINE) IN HALOGENATED HYDROCARBON (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: POISONING BECAUSE OF POSSIBLE INDUCTION OF
VENTRICULAR FIBRILLATION.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: RSLT IN NO INGEST OF DEHP. THERE IS NO EVIDENCE
OF CANCER DUE TO ISOLATED INCIDENTS OF INGEST, SUCH (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: AS ACCIDENTAL INGEST. A QUANTITIVE RISK ASSESSMENT
DEMONSTRATES THAT DEHP IN LIQUID PAPER IS NOT A (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: SIGNIFICANT RISK TO HUMANS BECAUSE OF ITS LOW CONC
& LOW EXPOSURE POTNTL. NO SMOKING IN AREA OF USE. (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: DO NOT USE IN THE GENERAL VICINITY OF ARC WELDING,
OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV RADIATION (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: MAY CAUSE THE FORMATION OF HCL &/OR PHOSGENE .
RTECS #:9999999ZZ
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:ING 1: EVAP RATE: SLOWER/ETHER. SOL IN H*20: <1%.
RTECS #:9999999ZZ
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:RESINS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: ORL(RAT) >5 ML/KG (ESTIMATED)
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL: NO ADVERSE EFTS ANTICIPATED
FROM NORMAL USE. IF VAPS ARE DELIB CONC/INHALED (ABUSE), FOLLOWING
SYMPS MAY OCCUR: RESP IRRIT/DIZZ/ DROW/HDACH/NAUS/UNCONS/CARDIAC
SENSIT (ABNORMAL HEARTBEAT)/COMA & DEATH. (MUSTARD OIL IS ADDED TO
THE PROD AS AN ABUSE DETERRENT). INGEST: NO ADVERSE EFTS
ANTICIPATED (EFTS OF OVEREXP)
Explanation of Carcinogenicity:DI(2-ETHYLHEXYL)PHTHALATE: GROUP
2B(IARC); GROUP 2 (NTP).
Effects of Overexposure:HLTH HAZ: FROM NORMAL USE. DEPENDING ON AMT
INGEST, MOST OF THE SYMPS DESCRIBED IN INHAL MAY OCCUR. ESTD LD50
IN RATS IS >5 ML/KG OR BETWEEN 1 PINT & 1 QT IN HUMANS. SKIN CONT:
NO ADVERSE EFTS ANTICIP ATED FROM NORMAL USE. IRRIT MAY OCCUR IF
CONT IS PRLNG/RPTD. SKIN ABSORPTION: NO ADVERSE EFTS ANTICIPATED
(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR A MINIMUM OF 15 MIN. IF
IRRIT PERSISTS, OBTAIN MED ATTN. SKIN: WASH W/SOAP & WATER. INHAL:
REMOVE FROM SOURCE OF EXPOS. TREAT SYMPTOMATICALLY. 02 MAY BE
ADMINISTERED. SEEK MED ATTN IMMED. REF TO "NOTES TO MD". INGEST:
CONSULT MD. NOTES TO MD: THE FORMULATION CONTAINS <5% PETROLEUM
DISTILLATES. INDUCTION OF VOMIT SHLD BE CONSIDERED AT THE
DISCRETION (ING 11)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F,>93C
Extinguishing Media:AS FOR ADJACENT FIRE: DRY CHEMICAL, FOAM, CO2,
WATER FOG.
Fire Fighting Procedures:IN FIRES INVOLVING LARGE QUANTITIES OF
PRODUCT, USE NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONC VAPOR OF 1,1,1-TRICHLOROETHANE CAN
BURN, PRODUCING HAZARDOUS DECOMPOSITION PRODUCTS. THERMAL
DECOMPOSITION PRODUCTS MAY INCLUDE HCL & PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL CLEAN UP: PICK UP SPILLS WITH TOWELS,
TISSUES, ETC.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO UNUSUAL HNDLG/STOR WHEN USED AS
DIRECTED. WHEN STORE IN LARGE QTYS (AS IN WHSE), IT SHLD BE IN A
WELL-VENTILATED, COOL AREA.
Other Precautions:PROD IS NON-HAZ WHEN USED AS DIRECTED IN A
OFFICE/ROOM W/NORMAL AIR CIRCULATION. BASED ON ANIMAL FEEDING
STUDIES, DI(2-ETHYLHEXYL) PHTHALATE IS LISTED BY IARC/NTP AS A POSS
HUMAN CARCIN, IF INGESTED.NORMAL USE OF THIS PROD WOULD (ING 13)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE UNDER NORMAL USE CONDITIONS. IF NECESSARY,
USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN .
Ventilation:NONE UNDER NORMAL USE CONDITIONS. CONSULT LOCAL SAFETY/HLTH
AUTHORITIES IF ADDL GUIDANCE IS NECESSARY .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S PART NO: FLUID - WHITE & COLORS. % VOLAT: APPROX 50. EFTS OF
OVEREXP: FROM NORMAL USE. SOLV CAN BE ABSORBED THROUGH SKIN (PRLNG
CONT), BUT NOT LIKELY IN ACUTELY TOXIC AMTS. EYE: IRRITATION. CHLO
ROCARBON MATLS HAVE PRDCED SENSIT OF THE MYOCARDIUM TO EPINEPHRINE
IN LAB ANIMALS & MAY HAVE A SIMILAR EFT IN (ING 9)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:INGRED 1
Vapor Pres:INGRED 1
Vapor Density:INGRED 1
Spec Gravity:APPROX 1.7
Evaporation Rate & Reference:INGRED 2
Solubility in Water:INGRED 2
Appearance and Odor:WHITE FLUID WITH A PUNGENT SOLVENT ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
FOR SOLVENT: STRONG ALKALIS/OXIDIZERS; ALUMINUM, ZINC & OTHER REACTIVE
METALS (E.G., POTASSIUM, SODIUM MAGNESIUM).
Stability Condition to Avoid:CONTACT W/OPEN FLAME OR OTHER HIGH
TEMPERATURE SOURCE.
Hazardous Decomposition Products:THERMAL DEGRADATION, E.G., OPEN FLAME,
CAN PRODUCE SMALL AMOUNTS OF PHOSGENE, HYDROGEN CHLORIDE &
CHLORINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH APPLICABLE FEDERAL,
STATE, AND LOCAL LAWS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:ORIGINAL FORMULA HEAVY DUTY HAND CLEANER, 1115
Preparer's Name:DONALD H SINNER
CAGE:GO199
CAGE:GO199
CAGE:02905
============= Composition/Information on Ingredients =============
Ingred Name:GLYCOLS, POLYETHYLENE MONO(NONYLPHENYL) ETHER; (NONIONIC
SURFACTANTS)
CAS:9616-45-9
RTECS #:MD0905000
Fraction by Wt: 3-7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STODDARD SOLVENT; (PETROLEUM DISTILLATES)
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 40-70%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)
LIGHT PARAFFINIC; (PETROLEUM DISTILLATES)
CAS:64742-55-8
RTECS #:PY8036501
Fraction by Wt: 40-70%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MAY CAUSE IRRITATION.
SKIN: PROLONGED CONTACT MAY RESULT IN CONTACT DERMATITIS WHICH IS
CHARACTERIZED BY DRYNESS, CHAPPING, AND REDDENING. INGESTION:
INGESTION OF SMALL QUANTITIES IS USUA LLY NOT HARMFUL UNLESS
VOMITING OCCURS.CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN OR RESPIRATORY
CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER FOR AT LEAST 15 MINUTES. IF CONDITION
WORSENS/IRRITATION PERSISTS, CONTACT MD. INGESTION: DO NOT INDUCE
VOMITING. IF VOMITING OCCURS, LOWER THE PERSON'S HEAD BELOW THEIR
KNEES TO AV OID ASPIRATION. CONTACT MD/POISON CONTROL CENTER. SKIN:
FLUSH W/COPIOUS AMOUNTS OF WATER. SEE MD . INHALATION: REMOVE TO
FRESH AIR. SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>201F,>94C
Lower Limits:1.1%
Upper Limits:6.0%
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CARBON DIOXIDE, DRY
CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DENSE SMOKE MAY BE GENERATED DURING
COMBUSTION. CARBON MONOXIDE, CARBON DIOXIDE, AND OTHER TOXIC OXIDES
MAY BE GENERATED AS PRODUCTS OF COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT ALLOW SPILL TO ENTER
SEWERS/WATERCOURSES. REMOVE ALL SOURCES OF IGNITION & ALLOW FOR
ADEQUATE VENTILATION. ABSORB ONTO INERT MEDIUM & COLLECT FOR
DISPOSAL IN APPROVED CONTAINER. RINSE AREA WELL W/WATER TO REDUCE
POSSIBLE SLIPPERY FLOOR HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL AREA AWAY FROM HEAT,
SPARKS, OPEN FLAME OR STRONG OXIDIZING MATERIALS. AVOID EYE CONTACT
AND PROLONGED SKIN CONTACT.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF USED AS DIRECTED. USE NIOSH
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:ROUTINE.
Supplemental Safety and Health
PH: 8.6-9.6 (UNDILUTED).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:180F,82C
Vapor Pres:10 @ 100F
Vapor Density:4-5
Spec Gravity:0.88 (H*2O=1)
pH:SUPDAT
Evaporation Rate & Reference:<1.0 (H*2O=1)
Solubility in Water:SLIGHT
Appearance and Odor:WHITE OPAQUE GEL, PLEASANT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO ALL LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: DURABOND D-3001 ACRYLIC COVE BASE ADHESIVE, 70048
Cage: 90300
Box: 277
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 90300
Box: 277
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:MAY IRRITATE EYES, SKIN, NOSE & RESPIRATORY
TRACT. INGESTION OF ETHYLENE GLYCOL CAN CAUSE GASTROINTESTINAL IRRITATION,
NAUSEA, VOMITING, DIARRHEA & IF CONSUMED IN SUFFICIENT QUANTITIES DEATH.
CH RONIC:REPORTS HAVE ASSOCIATED PERMANENTBRAIN & NERVOUS SYSTEM DAMAGE
WITH PROLONGED AND REPEATED (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:OCCUPATIONAL OVEREXPOSURE TO
SOLVENTS. INGESTION OF ETHYLENE GLYCOL IN EXCESS MAY LEAD TO RESPIRATORY
AND/OR CARDIAC FAILURE, AS WELL AS KIDNEY AND LIVER DAMAGE.
Medical Cond Aggravated By Exposure: NONE KNOWN.
First Aid: EYE:FLUSH W/LG AMTS OF WATER FOR @ LEAST 15 MINS. CONT PHYS IMMED.
SKIN:WASH W/SOAP AND WATER. INHAL:REMOVE TO FRESH AIR. CONT PHYS IMMEDIATELY.
INGEST:DO NOT INDUCE VOMITING. CONT PHYS/REGIONAL POISO N CONTROL CENTER
IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: USE ABSORBENT MATERIAL OR SCRAPE UP DRIED MATERIAL
AND PLACE INTO CONTAINERS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF ACCORDING TO FEDERAL, STATE AND LOCAL
STANDARDS. DO NOT REUSE EMTPY CONTAINERS.
Handling And Storage Precautions: STORE AWAY FROM CAUSTICS AND OXIDIZERS. KEEP
CNTNRS TIGHTLY CLSD WHEN NOT IN USE. KEEP OUT OF REACH OF CHILDREN.
Other Precautions: KEEP CONTAINERS FROM EXCESSIVE HEAT AND FREEZING.
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND INHALING VAPORS MAY BE
HARMFUL OR FATAL.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: >200F,>93C
Extinguishing Media: FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). USE WATER SPRAY TO COOL EXPOSED CONTAINER.
Unusual Fire/Explosion Hazard: NONE KNOWN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT REQD UNDER NORMAL USAGE & W/ADEQ VENT. SEE
VENTILATION SECTION. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: PROVIDE SUFFICIENT MECH VENT (LOC/GEN EXHAUST) TO MAINTAIN EXPOS
BELOW PEL & TLV. VAPS ARE HVR/AIR & WILL (SUPDAT).
Other Protective Equipment: ANSI APPRVD EMERGENCY EYE WASH & DELUGE SHOWER (FP
N).
Work Hygienic Practices: WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDITIONAL INFORMATION (FP N). VENT:COLLECT IN LOW AREAS. CHECK
LOW AREAS (BASEMENTS, SUMPS, ETC) BEFORE ENTERING.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212F,100C
Vapor Pres: 17.5 @ 20C
Vapor Density: >1
Spec Gravity: 1.5 (H*2O=1)
Solubility in Water: NOT KNOWN
Appearance and Odor: OFF-WHITE PASTE WITH SWEET ODOR.
Percent Volatiles by Volume: 40-45
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXCESSIVE HEAT AND FREEZING.
Materials To Avoid: STRONG OXIDIZERS AND CAUSTICS.
Hazardous Decomposition Products: NORMAL COMBUSTION PRODUCTS, I.E. CO*X, NO*X.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: DURABOND D-3001 ACRYLIC COVE BASE ADHESIVE, 70048
Cage: 90300
Company Name: DAP INC.
PO Box: 277
Zipcode: 45401-0277
Label Required IND: Y
Date Of Label Review: 06/26/1995
Status Code: C
Label Date: 06/26/1995
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:MAY IRRITATE EYES, SKIN, NOSE &
RESPIRATORY TRACT. INGESTION OF ETHYLENE GLYCOL CAN CAUSE GASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING, DIARRHEA & IF CONSUMED IN SUFFICIENT
QUANTIT IES DEATH. CHRONIC:REPORTS HAVE ASSOCIATED PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE WITH PROLONGED AND REPEATED OCCUPATIONAL OVEREXPOSURE
TO SOLVENTS. INGESTION OF ETHYLENE GLYCOL IN EXCESS MAY LEAD TO RESPIRATORY
AND/OR CARDIAC FAILURE, AS WELL AS KIDNEY AND LIVER DAMAGE.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:06105 POLY (ETHYLENE OXIDE)
CAGE:9C365
CAGE:32939
CAGE:9C365
============= Composition/Information on Ingredients =============
Ingred Name:POLYETHYLENE GLYCOL; POLYOXYETHYLENE; PEG 400; PEG 75; PEG
4000
CAS:25322-68-3
RTECS #:TQ3500000
Fraction by Wt: >93%
Other REC Limits:10 MG/CUM
Ingred Name:SILICON DIOXIDE, CELITE 322, AMORPHOUS SILICA GEL*95-4*
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <3%
OSHA PEL:80 MG/CUM
ACGIH TLV:0.2 MG/CUM
Ingred Name:CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: <4%
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:ETHYLENE OXIDE (SUSPECTED HUMAN CARCINOGEN BY ACGIH, IARC,
& OSHA; IARC GROUP 1; SUSP CARCINOGEN BY NTP) *95-4*
CAS:75-21-8
RTECS #:KX2450000
Fraction by Wt: <0.0005%
ACGIH TLV:1.8 MG/CUM (A2)
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:FINE POWDER COULD CAUSE IRRITATION TO
THE EYES & RESPIRATORY SYSTEM. INGESTION: SLIGHTLY TOXIC. EYES:
DUST MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, ABDOMINAL DISCOMFORT, VOMITING,
DIARRHEA, REDNESS, SWELLING
======================= First Aid Measures =======================
First Aid:SKIN; WASH W/COPIOUS AMOUNTS OF WATER. EYES: FLUSH W/WATER
FOR 15 MINS. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR AS
NEEDED. INGESTION: DRINK 1-2 GLASSES OF WATER & INDUCE VOMITING.
OBTAIN MEDI CAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO2, DRY CHEMICAL POWDER, FOAM
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE EQUIPMENT. USE WATER SPRAY TO DISPERSE VAPOR.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP. DON'T RAISE DUST. FLOORS CAN BE
SLIPPERY ESPECIALLY WHEN WET. USE SWEEPING COMPOUND FOR CLEANUP.
APPLY LAUNDRY BLEACH TO AREA. ALLOW TO STAND 10 MINS & FLUSH
THOROUGHLY W/WATER. REPEAT IF NE CESSARY.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE MATERIAL AT ROOM TEMP. KEEP
STORAGE CONTAINER TIGHTLY CLOSED. TRACES OF ETHYLENE OXIDE MAY BE
PRESENT/ACCUMULATE IN THE HEAD SPACE OF CONTAINERS
Other Precautions:AVOID CONTACT W/SKIN & EYES. DON'T INHALE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST RESPIRATOR, IF NEEDED.
Ventilation:MECHANICAL (GENERAL)
Other Protective Equipment:SAFETY SHOWER, EYE BATH
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
TREAT PRODUCT AS A NUISANCE DUST W/TLV OF 10 MG/CUM.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:143-152.6F
Spec Gravity:1.2
Solubility in Water:COMPLETE
Appearance and Odor:WHITE POWDER W/MILD AMMONIACAL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROXYL COMPOUNDS
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CARBON OXIDES
Conditions to Avoid Polymerization:HIGH TEMPERATURES
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL/DISPOSE OF IN ACCORDANCE W/LOCAL, STATE
& FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KAISER-PERMANENTE
CAGE:KO798
CAGE:86467
CAGE:KO798
============= Composition/Information on Ingredients =============
Ingred Name:PORTLAND CEMENT
CAS:65997-15-1
RTECS #:VV8770000
Other REC Limits:5 MG/M3 RDUST
OSHA PEL:30 MPPCF
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRIT. INHAL: UPPER RESP TRACT
IRRIT. SKIN: ALKALI BURNS. CHRONIC: ALLERGIC DERMATITIS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYE: IRRIGATE W/WATER. CALL DR
IMMED. INGEST: GIVE WATER. INDUCE VOMIT. CALL DR IMMED.
===================== Fire Fighting Measures =====================
Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NA
Fire Fighting Procedures:NA
Unusual Fire/Explosion Hazard:NA
================== Accidental Release Measures ==================
Spill Release Procedures:USE DRY CLEANUP METHODS TO MINIMIZE AIRBORNE
DISPERSION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR IF DUSTY.
Ventilation:PROVIDE VENTILATION TO MINIMIZE AIRBORNE DISPERSION.
Other Protective Equipment:BARRIER CREAM, BOOTS, CLOTHING.
Work Hygienic Practices:SHOWER W/SOAP & WATER AFTER WORK.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:3.15
Evaporation Rate & Reference:NA
Solubility in Water:SLIGHT
Appearance and Odor:GRAY POWDER, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:RETURN TO CONTAINER FOR LATER USE OR DISPOSE OF
AS COMMON WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P101 PARADICHLOROBENZENE
CAGE:GO409
CAGE:GO409
============= Composition/Information on Ingredients =============
Ingred Name:FREON 113, 1,1,2,-TRICHLORO-1,2,2,-TRIFLUOROETHANE,
TRICHLOROTRIFLUROETHANE *95-1*
CAS:76-13-1
RTECS #:KJ4000000
Other REC Limits:1000 PPM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ozone Depleting Chemical:1
Ingred Name:SILVER NITRATE
CAS:7761-88-8
RTECS #:VW4725000
OSHA PEL:10 UG/CUM
ACGIH TLV:10 UG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *95-2*
CAS:108-88-3
RTECS #:XS5250000
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *95-2*
CAS:1330-20-7
RTECS #:ZE2100000
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS *95-1*
CAS:67-56-1
RTECS #:PC1400000
Other REC Limits:200 PPM
OSHA PEL:260 MG/CUM
ACGIH TLV:262 MG/CUM (SKIN)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:O-CRESOL*95-1*
CAS:95-48-7
RTECS #:GO6300000
OSHA PEL:22 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2,4-DICHLOROPHENOXY) ACETIC ACID; (2,4-D)
CAS:94-75-7
RTECS #:AG6825000
OSHA PEL:10 MG/CUM
ACGIH TLV:10 MG/CUM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:METHOXYCHLOR (IARC CARCINOGEN - GROUP 3) *95-1*
CAS:72-43-5
RTECS #:KJ3675000
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SEC-BUTANOL ALCOHOL
CAS:78-92-2
RTECS #:EO1750000
Other REC Limits:100 PPM
OSHA PEL:150 PPM
ACGIH TLV:303 MG/CUM
Ingred Name:GLYCOL ETHERS
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE) (CHLOROTHENE NU),
AEROTHANE TT, CHLOROTHENE (IARC CARC - GROUP 3)*95-2*
CAS:71-55-6
RTECS #:KJ2975000
Other REC Limits:450 PPM STEL
OSHA PEL:350 PPM
ACGIH TLV:350 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:DICHLOROMETHANE (METHYLENE CHLORIDE) (SUSP HUMAN CARC BY
ACGIH, SUSP ANIM CARC BY IARC; NTP - IARC GROUP 2B) *95-1*
CAS:75-09-2
RTECS #:PA8050000
ACGIH TLV:174 MG/CUM (A2)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYLENE GLYCOL, GLYCOL
CAS:107-21-1
RTECS #:KW2975000
Other REC Limits:10 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BAYGON; PROPOXURE; 2-(1-METHYLETHOXY) PHENOL
METHYLCARBAMATE; O-ISOPROPOXYPHENYLMETHYLCARBAMATE
CAS:114-26-1
RTECS #:FC3150000
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PERCHLOROETHYLENE (TETRACHLOROETHYLENE) (SUSPECTED ANIMAL
CARCINOGEN BY NTP & IARC - GROUP 2B) *95-1*
CAS:127-18-4
RTECS #:KX3850000
Other REC Limits:50 PPM
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:NITRILOTRIACETIC ACID, NTA, TRIGLYCINE (SUSPECTED
CARCINOGEN BY IARC & NTP, IARC GROUP 2B) *95-1*
CAS:139-13-9
RTECS #:AJ0175000
Ingred Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN, IARC
GROUP 3) *95-2*
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:PHOSPHORIC ACID
CAS:7664-38-2
RTECS #:TB6300000
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SULFURIC ACID (CONFIRMED HUMAN CARCINOGEN BY IARC - GROUP
1) *95-1*
CAS:7664-93-9
RTECS #:WS5600000
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM=IC
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ZINC
CAS:7440-66-6
RTECS #:ZG8600000
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HYDROCHLORIC ACID, HYDROGEN CHLORIDE, MURIATIC ACID
HYDROCHLORIDE
CAS:7647-01-0
RTECS #:MW4025000
Other REC Limits:7 PPM
OSHA PEL:5 PPM
ACGIH TLV:C 11 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:FORMALDEHYDE, FORMALIN (SUSPECTED HUMAN CARCINOGEN BY IARC;
ACGIH; SUSPECTED CARCINOGEN BY NTP; IARC - GROUP 2A) *95-1*
CAS:50-00-0
RTECS #:LP8925000
ACGIH TLV:0.37 MG/CUM IC (2A)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:P-DICHLOROBENZENE, 1,4-DICHLOROBENZENE (PARA); BENZENE,
P-DICHLORO; PARADICHLORBENZENE(ANIMAL CAR IARC/NTP GRP 2B)*95-1*
CAS:106-46-7
RTECS #:CZ4550000
Fraction by Wt: 99%
Other REC Limits:75 PPM A2 CARCINOGEN
OSHA PEL:75 PPM
ACGIH TLV:75 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: IRRITATION/BURNS TO UPPER
RESPIRATORY SYSTEM, INCLUDING NOSE, MOUTH & THROAT. EYES:
IRRITATION. SKIN: IRRITATION, BURNS. INGESTION: IRRITATION, BURNS
TO MOUTH, THROAT & STOMACH.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, BURNS
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. INHALATION:
REMOVE TO FRESH AIR. INGESTION: INDUCE VOMITING. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:150F
Extinguishing Media:WATER, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING & SELF CONTAINED
RESPIRATORY PROTECTION.
Unusual Fire/Explosion Hazard:HIGHLY TOXIC GASES (CHLORIDES & CHLORINE)
CAN BE EVOKED IN FIRES OF THIS PRODUCT.
================== Accidental Release Measures ==================
Spill Release Procedures:SCRAPE UP/ABSORB ON CLAY, SAWDUST/OTHER
ABSORBENT MATERIAL IN DRUM & DISPOSE OF IN APPROVED CHEMICAL
LANDFILL IAW/FEDERAL, STATE & LOCAL REGULATIONS. BURY IN CHEMICAL
LANDFILL.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE NEAR STRONG OXIDIZING
AGENTS. KEEP AWAY FROM HEAT & FLAME.
Other Precautions:AVOID SKIN, EYE CONTACT. AVOID INHALATION OF DUST &
VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:LOCAL EXHAUST, MECHANICAL NOT REQUIRED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:345.2F
Vapor Pres:0.6
Vapor Density:5.1
Spec Gravity:1.458
Solubility in Water:0.08%
Appearance and Odor:WHITE CRYSTALS W/MOTH BALL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, FLAME
Hazardous Decomposition Products:CO, CO2, SMOKE, CHLORIDES, CHLORINE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. BURY IN CHEMICAL LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:F-161 AND F-167 OILS
CAGE:66164
CAGE:66164
============= Composition/Information on Ingredients =============
Ingred Name:LUBRICATING OIL(MIXTURE)
OSHA PEL:5 MG/M3, AS OIL MIST
ACGIH TLV:5 MG/M3, AS OIL MIST
Ingred Name:OTHER COMPONENTS (TYPE NOT SPECIFIED)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE TEMPORARY DISCOMFORT TO
EYES.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION.
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>250F,>121C
Extinguishing Media:CARBON DIOXIDE OR FOAM.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;CONTAIN FREE
MATERIAL IF POSSIBLE;USE SUITABLE INERT ABSORBENT MATERIAL AND
RECOVER FOR PROPER DISPOSAL IN AN APPROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE.DO NOT STORE
NEAR FLAMMABLE AND/OR EXPLOSIVES.
Other Precautions:TOXIC VAPORS MAY BE EVOLVED ABOVE 550F. PROVIDE
ADEQUATE VENTILATION IF USED ABOVE THIS TEMPERATURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT REQUIRED.USE WITH ADEQUATE
VENTILATION.
Ventilation:NORMAL ROOM VENTILATION
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER,WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.DO NOT SMOKE IN WORK AREA.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:<5 MM
Spec Gravity:1.13
Evaporation Rate & Reference:<1 (ETHER = 1)
Solubility in Water:< 0.1%
Appearance and Odor:CLEAR LIQUID,NO ODOR
Percent Volatiles by Volume:5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS MAY CAUSE A REACTION.
Hazardous Decomposition Products:FLUORINE PRODUCTS, SILICONE DIOXIDE,
CARBON DIOXIDE, TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES.DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LUBRIPLATE AUTOMATIC TRANSMISSION FLUID, TY
Preparer's Name:ROBERT J SIBILIN
CAGE:73219
CAGE:73219
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, UNSPECIFIED
Ingred Name:ADDITIVES
Ingred Name:ZINC COMPOUND
Fraction by Wt: <2%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. INGESTION:
ASPIRATION HAZARD. MAY CAUSE MILD TO SEVERE PULMONARY INJURY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/CLEAR WATER FOR 15 MINS. SKIN: WASH THOROUGHLY
W/SOAP & WARM WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION:
DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:370-430F
Lower Limits:0.9%
Upper Limits:7%
Extinguishing Media:FOAM, DRY CHEMICAL, CO2 OR WATER SPRAY (FOG)
Fire Fighting Procedures:COOL EXPOSED CONTAINERS W/WATER. USE AIR
SUPPLIED BREATHING EQUIPMENT FOR ENCLOSED OR CONFINED SPACES.
Unusual Fire/Explosion Hazard:EMPTY CONTAINERS RETAIN RESIDUE. DON'T
CUT, DRILL, GRIND OR WELD, AS THEY MAY EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER LIQUID, WASH REMAINDER W/SUITABLE
PETROLEUM SOLVENT OR ADD ABSORBENT. KEEP PETROLEUM PRODUCTS OUT OF
SEWERS & WATER COURSES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. DON'T HANDLE OR STORE NEAR HEAT, SPARKS, FLAME OR STRONG
OXIDANTS.
Other Precautions:AVOID BREATHING OIL MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT NEEDED
Ventilation:LOCAL EXHAUST: TO CAPTURE FUMES & VAPORS
Other Protective Equipment:OIL RESISTANT APRON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. CLEANSE SKIN THOROUGHLY AFTER CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>550F
Vapor Pres:<0.01
Vapor Density:>5
Spec Gravity:0.88-0.90
Evaporation Rate & Reference:(BU AC = 1): <0.01
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED, TRANSPARENT OIL W/MINERAL OIL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS LIKE LIQUID CHLORINE, CONCENTRATED OXYGEN.
Stability Condition to Avoid:HEAT, SPARKS, FLAME
Hazardous Decomposition Products:SULFUR DIOXIDE. IF INCOMPLETE
COMBUSTION, CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ABSORBED MATERIAL AT AN APPROVED
WASTE DISPOSAL FACILITY OR SITE IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SODIUM PHOSPHATE INJECTION
Preparer's Name:JOHN PURPURA
CAGE:32288
CAGE:32288
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM PHOSPHATE, DIBASIC, ANHYDROUS, DISODIUM PHOSPHATE
CAS:7558-79-4
RTECS #:WC4500000
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SODIUM PHOSPHATE MONOBASIC, MONOSODIUM PHOSPHATE
CAS:7558-80-7
RTECS #:WA1900000
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LARGE DOSES MAY CAUSE EYE, SKIN &
RESPIRATORY TRACT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:LARGE DOSES MAY CAUSE EYE, SKIN & RESPIRATORY
TRACT IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. INGESTION: FLUSH MOUTH OUT
W/WATER. SKIN/EYES: FLUSH W/WATER. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICAL, FOAM AS APPROPRIATE
FOR SURROUNDING FIRE & MATERIALS.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PERSONAL PROTECTIVE EQUIPMENT. VACUUM W/A
VACUUM CLEANER HAVING A HIGH EFFICIENCY PARTICULATE FILTER/ABSORB
LIQUID W/PAPER TOWELS. WIPE WORKING SURFACES TO DRYNESS, THEN WASH
W/SOAP & WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T MIX W/OTHER DRUGS. DON'T FREEZE.
Other Precautions:WHEN HANDLING PHARMACEUTICAL PRODUCTS, AVOID ALL
CONTACT & INHALATION OF DUST/FUMES/MIST/VAPORS ASSOCIATED
W/PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH APPROVED RESPIRATOR SHOULD BE AVAILABLE.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:DISPOSABLE PROTECTIVE APPAREL
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS SOLUTION W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OTHER DRUGS.
Stability Condition to Avoid:FREEZING.
Hazardous Decomposition Products:TOXIC FUMES WHEN HEATED TO
DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T MIX W/OTHER SUBSTANCES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LAC. ACR GREEN 14187 ID794430
Preparer's Name:W. A. ELLISON
CAGE:61196
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:LEAD CHROMATE (SARA 313)
CAS:7758-97-6
RTECS #:GB2975000
Fraction by Wt: 15%
Other REC Limits:*.1000 MG/M3 CEILING
OSHA PEL:.0500 MG/M3*
ACGIH TLV:0.0500 MG/M3
Ingred Name:CYCLOHEXANONE (VAPOR PRESSURE 2 MM HG @ 20C) (SKIN) (LFL:
1.1)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ISOBUTYL KETONE (SARA 313) (VAPOR PRESSURE 16 MM HG
@ 20C) (LFL: 1.0 UFL:8.0)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE (SARA 313) (VP: 180 MM HG 20C) (LFL: 2.6 UFL:
13.0)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BUTYL BENZYL PHTHALATE (SARA 313) (LFL: .3)
CAS:85-68-7
RTECS #:TH9990000
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ISOPROPYL ALCOHOL (VAPOR PRESSURE 33 MM HG @ 20F) (LFL: 3.0
UFL: 13.0)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM/500 PPM STEL
ACGIH TLV:400 PPM/500 PPM STEL
Ingred Name:METHYL ETHYL KETONE (SARA 313) (VAPOR PRESSURE 70 MM HG @
20C) (LFL: 2.0 UFL: 10.0)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/300 PPM STEL
ACGIH TLV:200 PPM/300 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC: 4.99 LB/GL LESS WATER & NPRS*; 599 G/L LESS WATER;
CALCULATED *NEGLIGIBLY PHOTOCHEMICALLY REACTIVE MATERIALS
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC: 16.58 LB/GAL SOLIDS; 1990 G/L SOLIDS; CALCULATED
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:IRRITATION (GASTROINTESTINAL, NOSE,
THROAT, EYE, SKIN). LUNG ASPIRATION: CHEMICAL PNEUMONITIS-CAN BE
FATAL. CENTRAL NERVOUS SYS DEPRESSION. CORNEAL DAMAGE. SKIN
ABSORPTION, DEFATTING. OVEREXPOSURE: LI VER, BLOOD FORMING,
NERVOUS, URINARY & REPRODUCTIVE SYS DAMAGE. PERIPHERAL NEUROPATHY.
PERM BRAIN & NERVOUS SYS DAMAGE.
Explanation of Carcinogenicity:CHROMIUM & CERTAIN CHROMIUM COMPOUNDS
AND LEAD ARE LISTED AS CARCINOGENS.
Effects of Overexposure:INGEST: NAUSEA/VOMITING. INHALE: HEADACHES,
DIZZINESS, NAUSEA, CONFUSION. CHRONIC OVEREXPOSURE: NO APPETITE,
METALLIC TASTE IN MOUTH, ANXIETY, CONSTIPATION, NAUSEA, WEAKNESS,
INSOMNIA, HEADACHE, MUSCL E/JOINT PAIN, FINE TREMORS, NUMBNESS,
DIZZINESS, HYPERACTIVITY & COLIC. METAL FUME FEVER:FLU-LIKE, FEVER,
CHILLS, COUGH.
Medical Cond Aggravated by Exposure:TOLUENE MAY CAUSE KIDNEY, LUNG &
SPLEEN DAMAGE IN LAB ANIMALS. METHYL ETHYL KETONE MAY BE
EMBRYOTOXIC, FETOTOXIC & TERATOGENIC. METHYL ISOBUTYL KETONE MAY
DAMAGE KIDNEYS.
======================= First Aid Measures =======================
First Aid:INGEST: DO NOT INDUCE VOMITING. CALL POISON CONTROL,
EMERGENCY ROOM OR PHYSICIAN IMMEDIATELY. INHALE: REMOVE TO FRESH
AIR IMMEDIATELY. GIVE ARTIFICIAL RESPIRATION IF NEEDED. KEEP WARM &
QUIET. GET IMM EDIATE MEDICAL AID. EYE: FLUSH THOROUGHLY WITH LARGE
AMOUNTS OF WATER FOR 15 MIN. GET MEDICAL AID. SKIN: REMOVE
CONTAMINATED CLOTHES WASH AFFECTED AREA WITH SOAP & WATER.
PERSISTANT IRRIT/MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point:1F,-17C
Lower Limits:.3
Upper Limits:13.0
Extinguishing Media:USE NFPA CLASS B(CO2, ALL PURPOSE DRY CHEMICAL OR
ALCOHOL FOAM) FOR LIQUID FIRES. POLYMER FOAM PREFERRED FOR LARGE
FIRES
Fire Fighting Procedures:USE SCBA. WATER MAY BE INEFFECTIVE, USE TO
COOL CNTNRS(FOG NOZZLE PREFERABLE) TO PREVENT PRESSURE
BUILD-UP&AUTO-IGNITION/EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:EMERGENCY CONDITIONS:OVEREXPOSURE TO
DECOMP PRODUCTS MAY CAUSE A HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMED APPARENT. GET MEDICAL AID. VAPORS MAY CAUSE FLASH FIRE
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. ELIMINATE IGNITE
SOURCES. DIKE AND CONTAIN. REMOVE WITH INERT MATERIAL (SAND, EARTH,
ETC). USE COVERED METAL CONTAINERS FOR RECOVERY OR DISPOSAL. USE
NON-SPARKING TOOLS. PREVENT CONTAMINATION OF SEWERS, STREAMS AND
GROUNDWATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 100F. LARGE
QUANTITY STORAGE: COMPLY WITH OSHA 29CFR1910.106. DO NOT TAKE
INTERNALLY. CONTAINERS CLOSED AFTER USE.
Other Precautions:DO NOT REUSE CONTAINERS FOR ANY PURPOSE. CONTAINERS
SHOULD BE GROUNDED AND BONDED TO THE RECEIVING CONTAINER. DO NOT
WELD, BRAZE OR CUT ON EMPTY CONTAINER. NEVER USE PRESSURE TO EMPTY.
DRUM IS NOT A P RESSURE VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESTRICTED AREA: NIOSH APPR'D CHEMICAL CARTRIDGE
RESPIRATOR. SPRAYING:MECHANICAL PREFILTER MAY BE REQUIRED. CONFINED
AREAS: NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR. EXCEEDED TLV
AREA: NIOSH/MSHA A PPR'D RESPIRATOR W/RIGHT PROTECT FACTOR.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST VENTILATION IN SUFFICIENT
VOLUME & PATTERN TO KEEP CONCENTRATIONS BELOW EXPOSURE LIMITS.
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT, SEE
OSHA STANDARDS FOR LEAD.
Work Hygienic Practices:DO NOT BREATHE SANDING DUST. WASH HANDS AND
FACE BEFORE EATING OR DRINKING.
Supplemental Safety and Health
HAZARDOUS/TOXIC, POSSIBLE HAZARDOUS/TOXIC INGREDIENTS/WASTE. REFER TO
OSHA 29CFR1910 FOR SAFETY/PROTECTIVE REQUIREMENTS. WELDING, BRAZING
OR TORCH CUTTING MATERIALS COATED WITH THIS PRODUCT MAY PRODUC E
METAL OXIDES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:133 TO 312F
Vapor Density:> AIR
Spec Gravity:1.1
pH:NA
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:NA
Appearance and Odor:PAINT
Percent Volatiles by Volume:69
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS.
Stability Condition to Avoid:AVOID EXCESS HEAT(>100F) & IGNITION
SOURCES.
Hazardous Decomposition Products:BURNING (INCL WELD/CUT) PRODUCES
SMOKE,CARBON MONOXIDE, CARBON DIOXIDE. OXIDES:
NITROGEN,CHROMIUM,LEAD MAY BE GENERATED.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW FEDERAL, STATE & LOCAL REGULATIONS &
LAWS. INCINERATE IN EPA PERMITTED FACILITY. DO NOT INCINERATE
CLOSED CONTAINERS. USE PRECAUTIONS FOR DISPOSAL OF HAZARDOUS/TOXIC
MATERIALS-D001/D008. USE HA ZARDOUS WASTE LANDFILL FOR USED
ABSORBENTS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:D-78 B DEVELOPER
CAGE:98733
CAGE:98733
============= Composition/Information on Ingredients =============
Ingred Name:MANUFACTURER STATES THAT THIS PRODUCT CONTAINS NO HAZARDOUS
COMPONENTS.
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: EXPOSURE TO DRY POWDER MAY CAUSE
IRRITATION. SKIN: EXPOSURE TO DRY POWDER MAY CAUSE IRRITATION.
INHALATION: EXPOSURE TO DRY POWDER MAY CAUSE IRRITATION OF NASAL
AND RESPIRATORY PASSAGES.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION. INHALATION:
IRRITATION OF NOSE AND THROAT.
Medical Cond Aggravated by Exposure:PERSON WITH PRE-EXISTING DISEASE
INVOLVING EYES, SKIN, OR RESPIRATORY TRACT MAY BE AT INCREASED RISK
FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. IF IRRITATION
PERSISTS GET MEDICAL ATTENTION. SKIN: WASH AREA WITH SOAP AND
WATER. INHALATION: MOVE TO FRESH AIR. IF SYMPTOMS PERSIST GET
MEDICAL ATTENTION. IN GESTION: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE DRY CHEMICAL, ALCOHOL FOAM, OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE PERSONAL EQUIPMENT.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS. DUST COULD FORM AN
EXPLOSIVE CLOUD.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR VACUUM AND COLLECT IN A SEALED
CONTAINER FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN SEALED DRY CONTAINERS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE REQUIRED USE NIOSH/MSHA APPROVED HIGH
EFFICIENCY DUST RESPIRATOR.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:CHEMICAL RESISTANT APRON. EYE WASH STATION
AND SAFETY SHOWER.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. AVOID CONTACT WITH EYES AND SKIN. DO NOT
BREATHE DUST.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:0.9
Solubility in Water:COMPLETE
Appearance and Odor:WHITE POWDER. SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PANEL ADHESIVE, NB300
Preparer's Name:REGINE LECLERC
CAGE:CBRND
CAGE:CBRND
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE VP: 140.0 @ 68F
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 20-30%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:BRTHG HIGH CONC OF
VAP/MIST MAY CAUSE IRRIT OF NOSE & THROAT & SIGNS OF NERVOUS SYS
DEPRESS (EG, DROW, DIZZ & LOSS OF COORDINATION). SKIN & EYES:MAY
CAUSE IRRIT. RPTD/PRLNG EXPOS MAY CAUSE REDNESS, BURNING, DRYING &
CRACKING OFSKIN. PERSONS W/PRE-EXISTING SKIN DISORDERS MAY BE MORE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SUSCEPTIBLE TO EFTS. INGEST:EXCESSIVE
QTYS MAY CAUSE IRRIT OF DIGEST TRACT, SIGNS OF NERVOUS SYS DEPRESS
(DROW, DIZZ & FATG) & ASPIR. MATL CAN ENTER LUNGS DURING
SWALLOWING. CHRONIC:RPTS ASSO C RPTD/PRLNG OCCUP OVEREXP TO SOLV
W/PERM BRAIN DMG. INTENTIONAL MISUSE BY DELIB CONC & INHAL PROD MAY
BE HARMFUL/FATAL.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/LG AMTS OF WATER FOR @ LEAST 15 MIN, LIFTING
UPPER & LOWER LIDS OCCAS. GET MED ATTN. SKIN:THORO WASH EXPOS AREA
W/SOAP & WATER. REMOVE CONTAM CLTHG & LAUNDER BEFORE RE-USE.
INGEST:DO NOT INDUCE VOMITING. KEEP PERSON WARM, QUIET & GET MED
ATTN. (ASPIR OF MATL INTO LUNGS DUE TO VOMIT CAN CAUSE CHEM PNEUM
WHICH CAN BE FATAL). INHAL:REMOVE TO FRESH AIR & IF BRTHG DFCLT,
ADMINISTER OXYGEN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:0F,-18C
Lower Limits:1.0%
Upper Limits:8.0%
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL CNTNRS. AVOID SPREADING BURNING
LIQUID W/WATER USED FOR COOLING PURPOSES.
Unusual Fire/Explosion Hazard:VAPORS MAY TRAVEL TO SOURCE OF IGNITION &
FLASH BACK. DO NOT USE JET STREAM OF WATER TO PREVENT SPREADING
FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:STAY UPWIND & AWAY FROM SPILL. KEEP ALL
SOURCES OF IGNITION FROM SPILL. IF SPILL IS INDOORS, VENTILATE AREA
OF SPILL. KEEP OUT OF DRAINS. USE SAND/OTHER INERT MATERIAL TO DAM
& CONTAIN MATERIAL. DO NO T FLUSH W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED. KEEP
CONTAINERS COOL, DRY & AWAY FROM SOURCES OF IGNITION. USE & STORE
THIS PROD W/ADEQUATE VENTILATION.
Other Precautions:ALL EMPTY CONTAINERS SHOULD BE DISPOSED OF IN AN
ENVIRONMENTALLY SAFE MANNER & IN ACCORDANCE W/GOVERNMENTAL
REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKPLACE EXPOSURE LIMITS OF PRODUCT IS
EXCEEDED, A NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED
IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL. ENGINEERING OR
ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL) &/OR LOC EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING & BOOTS.
Work Hygienic Practices:FOLLOW THE LABEL INSTRUCTIONS.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:149F,65C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:1.2 (H*2O=1)
Evaporation Rate & Reference:SLOWER/ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN COLORED PASTE, PETROLEUM ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT & FLAMES (IGNITION
SOURCES).
Hazardous Decomposition Products:TOXIC MATERIALS:CARBON DIOXIDE, CARBON
MONOXIDE, VARIOUS HYDROCARBONS, ETC.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL,
COUNTY, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PC-72 SEMI-GLOSS DARK GREEN
CAGE:90300
CAGE:90300
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 5-15%
Other REC Limits:350 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; PETROLEUM DISTILLATE,
HYDROTREATED
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 15-25%
OSHA PEL:400 PPM
ACGIH TLV:300 PPM
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: <5%
OSHA PEL:400 PPM
ACGIH TLV:300 PPM
Ingred Name:ZINC CHROMATE (HUMAN CARCINOGEN BY IARC, ACGIH)
CAS:37300-23-5
RTECS #:GB3300000
Fraction by Wt: 0.7-2.6%
ACGIH TLV:0.01 MG/CUM
Ingred Name:VOL ORGANIC CMPD: LESS WATER & EXEMPT SOLVENT = 413-422
G/L; VOC MATERIAL = 413-422 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION. SKIN: IRRITATION.
INHALATION: HARMFUL/IRRITATION OF NOSE & UPPER RESPIRATORY
TRACT/EFFECT TO BRAIN & NERVOUS SYSTEM CAUSING
DIZZINESS/HEADACHE/NAUSEA. INGESTION: HARMFUL/FATAL/VOMITIN
G/DIARRHEA/DEPRESSED RESPIRATION. ASPIRATION INTO LUNGS MAY CAUSE
CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:INHALATION: PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. SKIN: WASH
IMMEDIATELY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
INGESTION: DON'T INDUCE VOMITING. ASPIRATION HAZARD. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:105F
Lower Limits:1%
Upper Limits:7%
Extinguishing Media:FOAM, CO2, DRY CHEMICALS
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT, INCLUDING
SELF-CONTAINED BREATHING APPARATUS TO PROTECT FROM COMBUSTION
PRODUCTS. COOL EXPOSED CONTAINERS W/WATER.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE IF EXPOSED TO
EXTREME HEAT. COMBUSTIBLE LIQUID. VAPORS ARE HEAVIER THAN AIR &
WILL COLLECT IN LOW AREAS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM UP & REUSE EXCESS LIQUID. ABSORB
REMAINING LIQUID W/ABSORBENT MATERIAL & PLACE INTO CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. KEEP
CONTAINERS FROM EXCESSIVE HEAT & FREEZING. KEEP CONTAINERS TIGHTLY
CLOSED WHEN NOT IN USE.
Other Precautions:DON'T STORE AT TEMPS >105F. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING & INHALING VAPORS MAY BE HARMFUL OR
FATAL. STORE AWAY FROM CAUSTICS & OXIDIZERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF 8-HOUR EXPOSURE LIMIT OR VALUE IS EXCEEDED
FOR ANY COMPONENT, USE AN APPROVED NIOSH/OSHA RESPIRATOR.
Ventilation:SUFFICIENT MECHANICAL (LOCAL/GENERAL EXHAUST) TO MAINTAIN
EXPOSURE BELOW PEL & TLV.
Other Protective Equipment:EYEWASH, SOLVENT IMPERVIOUS APRON, BARRIER
CREAMS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:281-383F
Vapor Pres:5.1
Vapor Density:>1
Spec Gravity:1-1.2
Evaporation Rate & Reference:(N-BU AC = 1): <1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE LIQUID, DARK GREEN, GASOLINE-LIKE ODOR.
Percent Volatiles by Volume:46-48%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS OR CAUSTIC MATERIALS
Stability Condition to Avoid:EXTREME HEAT, ELECTRICAL EQUIPMENT,
SPARKS, OPEN FLAMES, TEMPS >105F, & OTHER SOURCES OF IGNITION,
FREEZING
Hazardous Decomposition Products:CO, CO2, & NITROGEN OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. DISCARDED MATERIAL SHOULD BE INCINERATED AT A
PERMITTED FACILITY. LIQUIDS CANNOT BE DISPOSED OF IN A LANDFILL.
COMBUSTIBLE LIQUID. UN126 3. D001 (IGNITABLE).
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:C T F CUTTING & TAPPING FLUID
Preparer's Name:V HAGEMAN
CAGE:EO177
CAGE:72653
CAGE:EO177
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE) (CHLOROTHENE NU),
AEROTHANE TT, CHLOROTHENE (IARC-GROUP 3) *95-1*
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 49%
Other REC Limits:450 PPM STEL
OSHA PEL:350 PPM
ACGIH TLV:350 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:CARBON DIOXIDE *95-1*
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 3%
Other REC Limits:10000 PPM
OSHA PEL:5000 PPM
ACGIH TLV:9000 MG/CUM
Ingred Name:PETRO CUTTING OIL
Fraction by Wt: 48%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE IRRITATION, DERMATITIS, CARDIAC
ARREST.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, MENTAL CONFUSION,
DROWSINESS, INCOORDINATION, UNCONSCIOUSNESS
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, CHEMICAL FOAM, DRY CHEMICAL
Fire Fighting Procedures:AVOID BREATHING COMBUSTION PRODUCTS, WHICH MAY
BE TOXIC.
Unusual Fire/Explosion Hazard:CAN MAY BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:PICKUP W/ABSORBENT MATERIAL. STORE IN SEALED
METAL CONTAINERS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT & MOISTURE. AVOID
TEMP >120F. CAN MAY BURST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF CONTAINED BREATHING APPARATUS/CHEMICAL
CARTRIDGE RESPIRATOR.
Ventilation:LOCAL EXHAUST VENTILATION. MECHANICAL: REQUIRED TO MEET
TLVS.
Other Protective Equipment:NECESSARY TO AVOID PROLONGED/REPEATED SKIN
EXPOSURE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:282F
Vapor Pres:100
Vapor Density:>1
Spec Gravity:1.13
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK BROWN LIQUID SULPHERIZED FAT W/CHLORINATED
HYDROCARBON ODOR.
Percent Volatiles by Volume:50
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM ALLOYS, SODIUM HYDROXIDE, LIQUID OXYGEN
Stability Condition to Avoid:EXTREME HIGH TEMP, HEAT, MOISTURE
Hazardous Decomposition Products:CO, CO2, CHLORINE, PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:LICENSED INCINERATOR IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PARASEPTS
CAGE:UO052
Contract Num:SP0450-00-M-SK22
CAGE:16029
CAGE:UO052
============= Composition/Information on Ingredients =============
Ingred Name:METHYL PARASEPT
CAS:99-76-3
RTECS #:DH2450000
Other REC Limits:5 MG/M3 RESPIR
Ingred Name:ETHYL PARASEPT ( ETHYL PARABEN; 4-HYDROXYBENZOIC ACID ETHYL
ESTER )
CAS:120-47-8
RTECS #:DH2190000
Other REC Limits:5 MG/M3 RESP DUST
Ingred Name:PROPYL PARASEPT (PROPYL PARABAN; 4-HYDROXYBENZOIC ACID
PROPYL ESTER)
CAS:94-13-3
RTECS #:DH2800000
Other REC Limits:5 MG.M3 RESP DUST
Ingred Name:BUTYL PARASEPT (BUTYL PARABEN; 4-HYDROXYBENZOIC ACID BUTYL
ESTER)
CAS:94-26-8
RTECS #:DH1980000
Other REC Limits:5 MG/M3 RESP DUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL MOUSE=3000 MG/KG METYLPARASEP
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: INHALATION OF DUST
MAY IRRITATE THE NOSE AND THROAT. EYE: MAY CAUSE EYE IRRITATION.
SKIN: PROLONGED EXPOSURE MAY CAUSE SKIN IRRITATION. INGESTION: MAY
BE HARMFUL IF SWALLOWED. CHRON IC: PROLONGED OR REPEATED CONTACT
MAY CAUSE SKIN IRRITATION. NO OTHER CHRONIC HEALTH HAZARD
INFORMATION IS AVAILABLE.
Effects of Overexposure:ACUTE: INHALATION: DUST MAY IRRITATE THE NOSE
AND THROAT. EYE: IRRITATION. SKIN: PROLONGED EXPOSURE MAY CAUSE
IRRITATION. INGESTION: MAY BE HARMFUL IF SWALLOWED. CHRONIC:
PROLONGED OR REPEATED CONTAC T MAY CAUSE SKIN IRRITATION.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:INHALATION: IIF OVERCOME BY EXPOSURE, REMOVE TO FRESH AIR
IMMEDIATELY. GIVE OXYGEN OR ARTIFICIAL RESPIRATION AS NEEDED.
OBTAIN EMERGENCY MEDICAL ATTENTION. EYE: IMMEDIATELY IRRIGATE WITH
PLENTY OF WAT ER FOR AT LEAST 15 MINUTES. IF IRRITATION DEVELOPS
OBTAIN MEDICAL ATTENTION. SKIN:REMOVE CONTAMINATED CLOTHING AS
NEEDED. WASH SKIN THOROUGHLY WITH MILD SOAP AND WATER. OBTAIN
MEDIAL ATTENTION IF IRRI TATION DEVELOPS. INGESTION: IF SWALLOWED
INDUCE VOMITING, OBTAIN EMERGENCY MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:ND
Autoignition Temp:>496.1C, 925.F
Extinguishing Media:USE DRY CHEMICAL, FOAM, OR CO2 TO EXTINGUISH FIRES.
Fire Fighting Procedures:WATER SPRAY MAY BE USED TO COOL THE FIRE. WEAR
SELF-CONTAINED POSITIVE PRESSURE BREATHING APPARATUS AND FULL
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:CONCENTRATED DUST IS AN EXPLOSION HAZARD.
PREVENT BUILDUP OF DUST ON FLOORS, WALLS, AND EQUIPMENT.
DECOMPOSITION UNDER FIRE CONDITIONS WILL GENERATE CARBON MONOCIDE
AND PHENOL AND MAY GENERATE OTHER T OXIC VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. SWEEP UP AND
REMOVE TO DISPOSAL CONTAINER. REPORT SPILL AS PER REGULATORY
REQUIREMENTS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED. STORE AWAY
FROM HIGH HEAT. PREVENT BUILDING OF DUST ON FLOORS.
Other Precautions:ISOLATE, VENT, DRAIN, WASH AND PURGE SYSTEMS OR
EQUIPMENT BEFORE MAINTENANCE OR REPAIR. REMOVE ALL IGNITION
SOURCES. CHECK ATMOSPHERE FOR EXPLOSIVESNESS AND OXYGEN
DEFICIENCIES. USE ADEQUATE PERSONAL PROTECTIVE EQUIPMENT. COMPLY
WITH REGULATIONS GOVERNING CONFIED SPACE ENTRY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF DUSTS ARE CREATED , USE NIOSH APPROVED DUST
RESPIRATOR.
Ventilation:USE WITH ADEQUATE LOCAL EXHAUST VENTILATION.
Other Protective Equipment:PROVIDE A SAFETY SHOWER EQUIPPED WITH AN
EYEWASH FOUNTAIN IN THE IMMEDIATE VICINTITY OF ANY POTENTIAL
EXPOSURE.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE PRACTICES. WASH HANDS
BEFORE EATING, DRINKING, OR SMOKING, OR USING TOILET FACILITIES.
PROMPTLY REMOVE CONTAMINATED CLOTHING AND WASH THOROUGHLY BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:>124.C, 255.2F
M.P/F.P Text:124 - 128 C
Decomp Temp:>270.C, 518.F
Decomp Text:518 - 572 F
Vapor Pres:NEGLIGIBLE @ 20C
Solubility in Water:SLIGHT
Appearance and Odor:WHITE TO IVORY, FREE FLOWING, ODORLESS POWDERS.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS. METALS MAY BE CORRODED BY MOIST PRODUCT. IRON
MAY CAUSE DISCOLORATION OF PRODUCT.
Stability Condition to Avoid:HEATING TO TEMPERATURES NEAR THE MELTING
POINT MAY CAUSE DECOMPOSITION, RELEASING CO2 AND PHENOL.
Hazardous Decomposition Products:DECOMPOSITION UNDER FIRE CONDITIONS
WILL GENERATE CARBON MONOXIDE AND PHENOL AND MAY GENERATE OTHER
TOXIC VAPORS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:NOTE: HEALTH STUDIES HAVE SHOWN THAT
EXPOSURES TO CHEMICALS POSE POTENTIAL HEALTH RISKS WHICH MAY VARY
FROM PERSON TO PERSON. THEREFORE EXPOSURE TO LIQUIDS, VAPORS,
MISTS, OR FUMES SHOULD BE MINIMIZED . LD50N ORAL MOUSE: FOR METHYL
3000 MG/KG; FOR ETHYL 5000 MG/KG; FOR PROPYL 6000 MG/KG; FOR BUTYL
PARASEPT IS NOT DETERMINED.
===================== Ecological Information =====================
Ecological:NOT PROVIDED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE MADE IN ACCORDANCE WITH
APPLICABLE GOVERNMENTAL REGULATIONS. DO NOT CONTAMINATE ANY
STREAMS, LAKES, OR PONDS.
=================== MSDS Transport Information ===================
Transport Information:NO INFORMATION PROVIDED.
===================== Regulatory Information =====================
SARA Title III Information:PARASEPTS ARE NOT LISTED AS AN EXTREMELY
HAZARDOUS SUBSTANCE UNDER SEC 302 OF SARA TITLE III. SEC 311/312:
NOT SUBJECT TO REPORTING REQUIREMENTS. SEC 313: DO NOT CONTAIN
INGREDIENTS INGREDIENTS AT A L EVEL OF 1% OR MORE ON THE LIST OF
TOXIC CHEMICALS.
Federal Regulatory Information:ALL INGREDIENTS ARE INCLUDED IN THE
CURRENT TSCA INVENTORY. OSHA HAZCOM (29 CFR 1910.1200): PARASEPTS
ARE NOT CONSIDERED HAZARDOUS UNDER THIS OSHA STANDARD.
State Regulatory Information:NO INFORMATION PROVIDED.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PERMA-CHINK WOOD RENEW
Preparer's Name:J. BARTLETT
CAGE:JO271
CAGE:JO271
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM PERCARBONATE
CAS:15630-89-4
Fraction by Wt: 40-60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM CARBONATE (2:1); (SODIUM CARBONATE)
CAS:497-19-8
RTECS #:VZ4050000
Fraction by Wt: 40-60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZENESULFONIC ACID, DODECYL-, SODIUM SALT; (SODIUM
DODECYLBENZENE SULFONATE) (CERCLA)
CAS:25155-30-0
RTECS #:DB6825000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE CONTACT:MAY CAUSE BURNS,
REDNESS, IRRITATION. INHALATION:MAY CAUSE IRRITATION OF MUCOUS
MEMBRANES. INGESTION:MAY CAUSE GASTROINTESTINAL IRRITATION. SKIN
CONTACT:MAY CAUSE IRRITATION. CHRONIC :NO ADVERSE LONG-TERM EFFECTS
ARE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/CLEAN WATER FOR AT LST 15 MINS; GET MED ATTN IF
IRRIT PERSISTS. INHAL:REMOVE INDIVIDUAL TO FRESH AIR. IF IRRIT
DEVELOPS, GET MED ATTN. INGEST:DO NOT INDUCE VOMIT. GIVE WATER/MILK
TO DRINK; GET MED ATTN IF IRRIT DEVELOPS. SKIN:REMOVE CONTAM
CLTHG. WASH AFFECTED AREA W/SOAP & WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:OXYGEN EVOLUTION AS A RESULT OF
DECOMPOSITION MAY BURST SEALED CONTAINERS & ACCELERATE BURNING RATE
OF OTHER COMBUSTIBLE MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP. DO NOT RETURN TO ORIGINAL CONTAINER.
BAG SPILL IN CLEAN, DRY PLASTIC BAGS. SMALL AMOUNTS MAY BE FLUSHED
DOWN DRAIN W/LARGE AMOUNTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL-VENTILATED
AREA IN ORIGINAL CONTAINER.
Other Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN USE. CONTACT
W/ORGANIC MATERIALS OR EXCESSIVE MOISTURE CAN RESULT IN SPONTANEOUS
COMBUSTION OF PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR FOR NUISANCE
DUSTS.
Ventilation:MAINTAIN ADEQUATE VENTILATION IN WORK AREA.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . CHEMICAL-RESISTANT APRON & RUBBER (SUPP
DATA)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PROT EQUIP:BOOTS, IF SKIN CONTACT IS LIKELY.
================== Physical/Chemical Properties ==================
Spec Gravity:1-1.5
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE, FREE-FLOWING POWDER; NO ODOR.
Percent Volatiles by Volume:1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALLIC SALTS, ORGANIC MATERIALS, OILS & GREASES.
Stability Condition to Avoid:EXCESSIVE HEAT OR MOISTURE.
Hazardous Decomposition Products:DECOMPOSITION FROM CONTACT
W/INCOMPATIBLE MATERIALS CAN CAUSE RAPID LIBERATION OF OXYGEN,
WHICH IS HIGHLY EXOTHERMIC.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF MATERIAL I/A/W ALL APPLICABLE
FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:OB2WA
CAGE:0872X
CAGE:0872X
CAGE:49956
============= Composition/Information on Ingredients =============
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
===================== Hazards Identification =====================
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
======================= First Aid Measures =======================
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
================== Accidental Release Measures ==================
======================Handling and Storage ======================
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-EXAM OF STOCK IN WHSE. SAFETY & HEALTH DATA DEVELOPED BY
DGSC-STF.
================== Physical/Chemical Properties ==================
HCC:A3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VICTOR TYPE V
CAGE:87316
CAGE:87316
============= Composition/Information on Ingredients =============
Ingred Name:SALTS; (OTHER SALTS)
Fraction by Wt: TRACE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PORTLAND CEMENT CONTAINING INGREDIENTS 2-9
CAS:65997-15-1
RTECS #:VV8770000
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TRICALCIUM SILICATE; (3CAO SIO*2)
CAS:12168-85-3
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DICALCIUM SILICATE; (2CAO SIO*2)
CAS:10034-77-2
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TRICALCIUM ALUMINATE; (3CAO AL*20*3)
CAS:12042-78-3
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TETRACALCIUM ALUMINOFERRATE; (4CAO AL2*O*3 FE*2O*3)
CAS:12068-35-8
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:GYPSUM; (CASO*4 2H*2O)
CAS:13397-24-5
RTECS #:MG2360000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CALCIUM OXIDE; (CAO)
CAS:1305-78-8
RTECS #:EW3100000
Fraction by Wt: TRACE
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:CALCIUM CARBONATE; (CACO*3)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: TRACE
OSHA PEL:15MG/M3 TDUST;5RDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: WET CEMENT, ESPECIALLY AS AN
INGREDIENT IN PLASTIC (UNHARDENED) CONCRETE, CAN DRY SKIN AND CAUSE
ALKALI BURNS. CEMENT DUST CAN IRRITATE EYES AND UPPER RESPIRATORY
SYSTEM. CHRONIC: CEMENT DUST C AN CAUSE INFLAMMATION OF LINING
TISSUE OF INTERIOR OF NOSE AND INFLAMMATION OF EYE. HYPERSENSITIVE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HEALTH HAZARDS: INDIVIDUALS MAY DEVELOP AN
ALLERGIC DERMATITIS (SKIN RASH).
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: IRRIGATE WITH WATER FOR AT LEAST 15 MINUTES. CONSULT
PHYSICIAN. SKIN: WASH EXPOSED AREAS WITH SOAP AND WATER.
INHALATION: REMOVE FROM EXPOSURE. SUPPORT BREATHING (GIVE
ARTIFICIAL RESPIRATION/OXYG EN) . INGESTION: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:NOT APPLICABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE CONDITIONS .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE DRY CLEANUP METHODS THAT DO NOT DISPERSE
DUST INTO AIR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PRECAUTIONS MUST BE OBSERVED BECAUSE
WET CEMENT BURNS WITH LITTLE WARNING-LITTLE HEAT IS SENSED.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN DUSTY ENVIRONMENTS, USE NIOSH/MSHA APPROVED
RESPIRATOR.
Ventilation:USE EXHAUST FANS TO CONTROL AIRBORNE DUST LEVELS.
Other Protective Equipment:USE BARRIER CREAMS, BOOTS AND CLTHG TO PROT
SKIN FROM PRLNGD CONT W/WET CEMENT, ESPEC IN PLASTIC (UNHARDENED)
CONCRETE.
Work Hygienic Practices:IMMEDIATELY AFTER WORKING WITH CEMENT, WORKERS
SHOULD SHOWER WITH SOAP AND WATER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:3.10-3.20
Solubility in Water:SLIGHT (0.1-1.0%)
Appearance and Odor:GRAY POWDER, NO ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL CAN BE RETURNED TO CONTAINER FOR LATER
USE, OR IT CAN BE DISPOSED OF AS A COMMON WASTE. DISPOSE OF IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-161-4671
Product ID: 00203 MASTER GASKET 518 KIT
Kit Part: Y
Cage: 7K128
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 7K128
=======================================================
Contractor Summary
=======================================================
Cage: 7K128
Cage: 05972
=======================================================
Item Description Information
=======================================================
Item Name: GASKET SET
=======================================================
Ingredients
=======================================================
Cas: 71-55-6
RTECS #: KJ2975000
CHLOROTHENE
% Wt: 95-100
Other REC Limits: 450 PPM STEL
OSHA PEL: 350 PPM
ACGIH TLV: 1910 MG/CUM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
Ozone Depleting Chemical: 1
------------------------------
Cas: 124-38-9
RTECS #: FF6400000
% Wt: 3-5
Other REC Limits: 10000 PPM
OSHA PEL: 5000 PPM
ACGIH TLV: 9000 MG/CUM
------------------------------
Cas: 75-65-0
RTECS #: EO1925000
% Wt: 1-3
Other REC Limits: 300 PPM
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM
------------------------------
Cas: 109-87-5
RTECS #: PA8750000
% Wt: 1-3
Other REC Limits: 1000 PPM
OSHA PEL: 3100 MG/CUM
ACGIH TLV: 3100 MG/CUM
------------------------------
Cas: 149-57-5
RTECS #: MO7700000
% Wt: 0.1-1
------------------------------
Cas: 58823-74-8
% Wt: 0.1-1
------------------------------
Cas: 22221-10-9
RTECS #: MO7708000
% Wt: 0.1-1
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: TOXICITY: POSSIBLE EYE IRRITANT. MODERATELY TOXIC BY
INGESTION.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: HEADACHE, ANUSEA, DIZZINESS, NARCOSIS AT
HIGH CONCENTRATION.
Medical Cond Aggravated By Exposure: 1,1,1-TRICHLOROETHANE: CNS, LIVER, HEART
DISEASE, ALCOHOLISM, SKIN DISORDERS, EYE PROBLEMS, RESPIRATORY DISORDERS.
2-ETHYLEXANOIC ACID: DERMATITIS.
First Aid: INGESTION: DON'T INDUCE VOMITING. KEEP CALM. INHALATION: REMOVE TO
FRESH AIR. SKIN: WASH W/SOAP & WATER. EYE: FLUSH FOR 15 MINS W/WATER.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ALLOW TO EVAPORATE W/GOOD VENTILATION. SOAK UP
RESIDUE IN AN INERT ABSORBENT. STORE IN A CLOSED CONTAINER UNTIL DISPOSAL.
Waste Disposal Methods: DON'T INCINERATE PRESSURIZED CANS. DISPOSE OF
IAW/LOCAL, STATE & FEDERAL REGULATIONS. UN #1950
Handling And Storage Precautions: STORE IN CLOSED CONTAINER. STORE BELOW 110F
TO PRESSERVE SHELF LIFE. AVOID PROLONGED BREATHING OF VAPOR. KEEP AWAY FROM
EYES.
Other Precautions: AVOID PROLONGED SKIN CONTACT.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: NONE
Extinguishing Media: CO2, FOAM, DRY CHEMICAL
Unusual Fire/Explosion Hazard: CANS MAY RUPTURE IN FIRES.
=======================================================
Control Measures
=======================================================
Ventilation: PROVIDE ADEQUATE VENTILATION TO MAINTAIN VAPOR CONCENTRATION BELOW
TLV.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 170F
Vapor Pres: <100
Vapor Density: 4.5
Spec Gravity: 1.32
Evaporation Rate & Reference: (ETHER=1): 2.7
Solubility in Water: INSOLUBLE
Appearance and Odor: GREEN LIQUID W/SHARP ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: FIRE
Materials To Avoid: ALUMINUM
Hazardous Decomposition Products: FORMALDEHYDE, SILICA FUME.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 00203 MASTER GASKET 518 KIT
Cage: 7K128
Company Name: LOCTITE CORP
Street: 705 N MT RD
Zipcode: 06111
Label Required IND: Y
Date Of Label Review: 08/12/1994
Status Code: C
Label Date: 08/12/1994
Origination Code: F
Skin Protection IND: YES
Signal Word: WARNING
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: TOXICITY: POSSIBLE EYE IRRITANT. MODERATELY TOXIC BY
INGESTION. TARGET ORGAN: DIGESTIVE TRACT.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GLYCEROL 87%, 86-88%, 49782
CAGE:63181
CAGE:63181
============= Composition/Information on Ingredients =============
Ingred Name:GLYCEROL
CAS:56-81-5
RTECS #:MA8050000
Minumum % Wt:86.
Maxumum % Wt:88.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAYBE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. CAUSES EYE AND SKIN IRRITATION.
MATERIAL MAY BE IRRITATING TO MUCOUS MEMBRANES AND UPPER
RESPIRATORY TRACT.CHRONIC: PROLONGED EXPOS URE CAN CAUSE NAUSEA,
HEADACHE AND VOMITING. TARGET ORGAN: KIDNEYS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES WITH COPIOUS
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. SKIN: IN CASE OF CONTACT,
IMMEDIATELY FLUSH SKIN WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST
15 M INUTES WHILE REMOVING CONTAMINATED CLOTHING AND SHOES.
INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. INGESTION:
WASH OUT MOUTH WITH WATER PROVIDED PERSON IS CONSCIOUS. CALL A
PHYSICIAN. WASH CONTAMINATED CLOTHING BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point:=160.C, 320.F
Autoignition Temp:=370.C, 698.F
Lower Limits:0.9%
Extinguishing Media:WATER SPRAY. CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH APPROVED RESPIRATOR, CHEMICAL
SAND OR VERMICULITE AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL.
VENTILATE AREA AND WASH SPILL SITE AFTER MATERIAL PICKUP IS
COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE VAPOR. AVOID CONTACT
WITH EYES, SKIN AND CLOTHING. AVOID PROLONGED OR REPEATED EXPOSURE.
WASH THOROUGHLY AFTER HANDLING. KEEP TIGHTLY CLOSED. STORE IN A
COOL, DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:<1 MM 20C
Vapor Density:3.1
Spec Gravity:1.227
Appearance and Odor:VISCOUS COLORLESS LIQUID.
================= Stability and Reactivity Data =================
STRONG OXIDIZING AGENTS. STRONG BASES.
Stability Condition to Avoid:PROTECT FROM MOISTURE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:GLYCEROL RTECS #: MA8050000. IRRIT DATA:
SKIN-RBT 500 MG/24H MLD 85JCAE -,207,1986. EYE-RBT 126 MG MLD BIOFX
9-4/1970. EYE-RBT 500 MG/24H MLD 85JCAE -,207,1986. TOXICITY DATA -
ORL-RAT LD50:1260 MG/KG FEPRA7 1,142,1945. IHL-RAT LC50:>570
MG/M3/1H BIOFX 9-4/1970. IPR-RAT LD50:4420 MG/KG RCOCB8
56,125,1987. SCU-RAT LD50:100 MG/KG NIIRDN 6,215,1982. IVN-RAT
LD50:5566 MG/KG ARZNAD 26,1581,1976. ORL-MU S LD50:4090 MG/KG
FRZKAP (6),56,1977. IPR-MUS LD50:8700 MG/KG ARZNAD 28,1579,1978.
SCU-MUS LD50:91 MG/KG NIIRDN 6,215,1982. IVN-MUS LD50:4250 MG/KG
JAPMA8 39,583,1950. ORL-RBT LD50:27 G/KG DMDJAP 31,2 76,1959.
(ECOLOGICAL INFO)
===================== Ecological Information =====================
Ecological:DATA NOT YET AVAILABLE. --TOXICOLOGICAL INFO: SKN-RBT
LD50:>10 G/KG BIOFX 9-4/1970. IVN-RBT LD50:53 G/KG NIIRDN
6,215,1982. ORL-GPG LD50:7750 MG/KG JIHTAB 23,259,1941. TARGET
ORGAN DATA - BEHAVIORAL ( HEADACHE). GASTROINTESTINAL (NAUSEA OR
VOMITING). PATERNAL EFFECTS (SPERMATOGENESIS, TESTES, EPIDIDYMIS,
SPERM DUCT). EFFECTS ON FERTILITY (MALE FERTILITY INDEX,
POST-IMPLANTATION MORTALITY). ONLY SEL ECTED REGISTRY OF TOXIC
EFFECTS OF CHEMICAL SUBSTANCES (RTECS) DATA IS PRESENTED HERE. SEE
ACTUAL ENTRY IN RTECS FOR COMPLETE INFORMATION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:CONTACT FLUKA CHEMICAL COMPANY FOR TRANSPORTATION
INFORMATION. --OTHER INFO: CFRGBR 29,1910.1000,1994. OSHA PEL
(CONSTRUC): 8H TWA 15 MG/M3, TOTAL DUST CFRGBR 29,1926.55,1994.
OSHA PEL (CONSTRUC): 8H TWA 5 MG/M3, RESPIRABLE FRACTION CFRGBR
29,1926.55,1994. OSHA PEL (SHIPYARD): 8H TWA 15 MG/M3, TOTAL DUST
CFRGBR 29,1915.1000,1993. OSHA PEL (SHIPYARD): 8H TWA 5 MG/M3,
RESPIRABLE FRACTION CFRGBR 29,1 915.1000,1993. OEL-AUSTRALIA:TWA 10
MG/M3 JAN 1993. OEL-BELGIUM:TWA 10 MG/M3 JAN 1993. OEL-FINLAND:TWA
20 MG/M3 JAN 1993. OEL-FRANCE:TWA 10 MG/M3 JAN 1993. OEL-THE
NETHERLANDS:TWA 10 MG/M3 JAN 1993. ( STATE REG INFO)
===================== Regulatory Information =====================
Federal Regulatory Information:EUROPEAN INFORMATION - IRRITANT. R 36/38
IRRITATING TO EYES AND SKIN. S 26 IN CASE OF CONTACT WITH EYES,
RINSE IMMEDIATELY WITH PLENTY OF WATER AND SEEK MEDICAL ADVICE. S
36 WEAR SUITABLE PROTECTIVE C LOTHING.
State Regulatory Information:N/P. --TRANSPORT INFO: OEL-UNITED
KINGDOM:TWA 10 MG/M3 JAN 1993. OEL IN BULGARIA, COLOMBIA, JORDAN,
KOREA CHECK ACGIH TLV. OEL IN NEW ZEALAND, SINGAPORE, VIETNAM CHECK
ACGIH TLV. NOHS 1974: HZD 35085; NIS 358; TNF 86657; NOS 198; TNE
1085329. NOES 1983: HZD 35085; NIS 310; TNF 67054; NOS 215; TNE
2135546; TFE 1346631. EPA TSCA SECTION 8(B) CHEMICAL INVENTORY. EPA
TSCA SECTION 8(D) UNPUBLISHED HEAL TH/SAFETY STUDIES. EPA TSCA TEST
SUBMISSION (TSCATS) DATA BASE, JUNE 1998.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KEROSENE NO. 1 FUEL OIL,ARCTIC GRADE FUEL O
CAGE:3X619
CAGE:3X619
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE
CAS:8008-20-6
RTECS #:OA5500000
Other REC Limits:NONE SPECIFIED
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 0.24%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:CUMENE (SARA III)
CAS:98-82-8
RTECS #:GR8575000
Fraction by Wt: 0.04%
Other REC Limits:NONE SPECIFIED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 0.09%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NAPHTHALENE (SARA III)
CAS:91-20-3
RTECS #:QJ0525000
Fraction by Wt: 0.34%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 PPM/15 STEL
ACGIH TLV:10 PPM/15 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA III)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 0.27%
Other REC Limits:NONE SPECIFIED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM; 9293
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 0.50%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0.53%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: PROLONGED
CONTACT MAY RESULT IN IRRITATION AND DERMATITIS. INHALATION: HIGH
CONCENTRATIONS MAY CAUSE NOSE, THROAT AND RESPIRATORY IRRITATION,
DIZZINESS, AND POSSIBLY UNCONSCIOU SNESS.
Explanation of Carcinogenicity:NIOSH FINDINGS SUGGEST "POTENTIAL
OCCUPATIONAL CARCINOGENIC HAZARD EXISTS IN HUMAN EXPOSURE TO DIESEL
EXHAUST."
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION, DERMATITIS.
INHALATION: NOSE, THROAT AND RESPIRATORY IRRITATION, DIZZINESS,
UNCONSCIOUSNESS. INGESTION: NAUSEA, VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH AREA WITH SOAP
AND WATER. INHALATION: MOVE TO FRESH AIR. IF NOT BREATHING GIVE
CPR. IF BREATHIN G DIFFICULT GIVE OXYGEN. GET MEDICAL ATTENTION.
INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:100F,38C
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:FOAM, WATER FOG, CARBON DIOXIDE, OR DRY CHEMICAL.
Fire Fighting Procedures:USE WATER TO KEEP FIRE EXPOSED CONTAINERS
COOL. IF SPILL HAS NOT IGNITED, USE WATER SPRAY TO DISPERSE VAPORS
AND PROVIDE PROTECTION FOR MEN TRYING TO STOP LEAK.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG GROUND A LONG DISTANCE TO AN IGNITION SOURCE AND
BACKFLASH.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. STOP LEAK. CONTROL
SPILL BY DIKING IF POSSIBLE.VENTILATE AREA. KEEP PRODUCT OUT OF
SEWERS AND WATERWAYS. ABSORB ON VERMICULITE, SAND, CLAY, EARTH OR
OTHER ABSORBENT AND TRANSF ER TO HOOD OR SHOVEL INTO CONTAINERS FOR
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT HANDLE OR STORE NEAR FLAME,
HEAT, SPARKS, OR STRONG OXIDANTS.STORAGE AREA SHOULD BE WELL
VENTILATED. AVOID BREATHING VAPORS.
Other Precautions:STORE AS NFPA CLASS II LIQUID.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CONFINED AREAS USE FULL FACE MASK EQUIPPED
WITH HYDROCARBON VAPOR CANISTER OR SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL/LOCAL EXHAUST VENTILATION TO
KEEP BELOW RECOMMENDED TLV/PEL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:285F,141C
Vapor Pres:2-3
Vapor Density:4
Spec Gravity:0.805
Evaporation Rate & Reference:0.04 (N-BUTYLACETATE=1)
Solubility in Water:NIL
Appearance and Odor:CLEAR, WATER WHITE TO STRAW LIQUID. HYDROCARBON
ODOR.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS LIKE CHLORINE, HYPOCHLORITES, CONCENTRATED
OXYGEN.
Stability Condition to Avoid:HEAT, SPARKS, FLAMES, IGNITION SOURCES.
Hazardous Decomposition Products:FUMES, SMOKE, AND CARBON MONOXIDE IN
CASE OF INCOMPLETE COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NITRIC ACID,50-70 %
CAGE:0TG10
Contract Num:SP0450-98-M-CM 84
CAGE:75656
CAGE:0TG10
============= Composition/Information on Ingredients =============
Ingred Name:NITRIC ACID (SARA III)
CAS:7697-37-2
RTECS #:QU5775000
Minumum % Wt:65.
Maxumum % Wt:70.
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 PPM/4 STEL
ACGIH TLV:2 PPM/4 STEL; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:30.
Maxumum % Wt:35.
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LC50 (INHALATION, RAT): 244 PPM NO2/30M
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYES, SKIN, RESPIRATORY
AND GASTROINTESTINAL TRACTS. ACUTE - POISON! DANGER! STRONG
OXIDIZER, CORROSIVE!. INHALATION OF VAPORS CAN RESULT IN BREATHING
DIFFICULTIES AND LEAD TO PNEUMONI A AND PULMONARY EDEMA, WHICH MAY
BE FATAL. VAPORS ARE IRRITATING AND MAY CAUSE DAMAGE TO EYES. MAY
CAUSE SEVERE BURNS AND PERMANENT EYE DAMAGE. CAN CAUSE SEVERE SKIN
BURNS, DEEP ULCERS AND STAIN SKIN A YELLOW OR YELLOW-BROWN COLOR.
SWALLOWING NITRIC ACID CAN CAUSE IMMEDIATE PAIN AND BURNS OF THE
MOUTH, THROAT, ESOPHAGUS AND GASTROINTESTINAL TRACT. CHRONIC -
VAPORS MAY CAUSE EROSION OF TEETH AND L UNG DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SEVERE IRRITATION, SEVERE BURNS; COUGH, NAUSEA,
NASAL DISCHARGE, RESPIRATORY FAILURE, REDNESS OF EYES, BLURRED
VISION, BURNING SENSATION IN MOUTH AND PHARYNX, SALIVATION,
ABDOMINAL PAIN, VOMITING BLOO D, DIARRHEA, HEMATURIA, DIFFICULTY
BREATHING, SHOCK, RAPID PULSE, DEATH, BLINDNESS, EROSION OF TEETH,
DEEP SKIN ULCERS, YELLOW SKIN STAIN, PAIN
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED CARDIOVASCULAR DISEASES MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:OBTAIN MEDICAL ATTENTION IMMEDIATELY. INHALED: REMOVE FROM
EXPOSURE TO FRESH AIR IMMEDIATELY. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
EYES: IMMEDIATELY FLUSH EYE WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES. OCCASIONALLY LIFTING THE UPPER AND LOWER LIDS. DO NOT
ALLOW VICTIM TO RUB OR KEEP EYES CLOSED. SKIN: FLUSH WITH LARGE
AMOUNT OF RUNNING WATER F OR AT LEAST 15 MINUTES. INGESTION: DO NOT
INDUCE VOMITING. IF VICTIM IS CONSCIOUS AND ALERT, WASH OUT MOUTH
WITH RUNNING WATER. GIVE LARGE QUANTITIES OF MILK OR WATER TO
DRINK.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY MAY BE USED TO KEEP FIRE EXPOSED
CONTAINERS COOL. DO NOT GET WATER INSIDE CONTAINER.
Fire Fighting Procedures:INCREASES THE FLAMMABILITY OF COMBUSTIBLE,
ORGANIC MATERIALS. IN THE EVENT OF A FIRE, WEAR FULL PROTECTIVE
CLOTHING AND NIOSH-APPROVED SELF-CONTAINED BREATHING APPARZATUS
WITH FULL-FACEPIECE OPERATED IN POSITIVE-PRESSURE MODE.
Unusual Fire/Explosion Hazard:REACTS EXPLOSIVELY WITH COMBUSTIBLE
ORGANIC OR READILY OZIDIZABLE MATERIALS SUCH AS: ALCOHOLS,
TURPENTINE, CHARCOAL, ORGANIC REFUSE, METAL POWDER,HYDROGEN
SULFIDE, ETC. REACTS WITH MOST METALS TO RELE ASE HYDOGEN GAS WHICH
CAN FORM EXPLOSIVE MIXTURES WITH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:OXIDIZING ACID. STOP LEAK IF POSSIBLE. AVOID
CONTACT WITH A COMBUSTIBLE MATERIAL (WOOD, PAPER, CLOTHING). WEAR
APPROPRIATE PERSONAL EQUIPMENT. ISOLATE HAZARD AREA. KEEP
UNPROTECTED PERSONNEL AWAY. DO NOT TOUCH SPILLED MATERIAL. CONTAIN
& RECOVER LIQUID WHEN POSSIBLE. NEUTRALIZE WITH ALKALINE MATERIAL.
ABSORB WITH AN INERT MATERIAL AND PLACE IN A CHEMICAL WASTE
CONTAINER. PREVENT ENTRY INTO SEWERS.
Neutralizing Agent:LIME, SODA ASH, SODIUM BICARBONATE, SODIUM CARBONATE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, VENTILATED
STORAGE AREA WITH ACID RESISTANT FLOORS AND GOOD DEAINAGE. PROTECT
FROM PHYSICAL DAMAGE. KEEP AWAY FROM HEAT, WATER, DIRECT SUNLIGHT,
AND INCOMPATIBLE MATERIALS. WHEN DILUTING, THE ACID SHOULD BE
ALWAYS BE ADDEDE SLOWLY TO WATER AND IN SMALL AMOUNTS.
Other Precautions:DO NOT WASH OUT CONTAINER AND USE IT FOR OTHER
PURPOSES. CORROSIVE!. EMPTY CONTAINERS RETAIN PRODUCT RESIDUES
(VAPORS, LIQUID) AND CAN BE HAZARDOUS; OBSERVE ALL WARNINGS AND
PRECAUTIONS LISTED ON THE LABEL. KEEP OUT OF REACH OF CHILDREN.
AVOID BREATHING VAPOR. DO NOT GET IN EYE, ON SKIN OR ON CLOTHI NG.
AVOID INGESTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED OR FOR SYMPTOMS OF OVER
EXPOSURE, WEAR A NIOSH-APPROVED SUPPLIED AIR, FULL-FACEPIECE
RESPIRATOR, AIRLINED HOOD, OR FULL-FACEPIECE, POSITIVE-PRESSURE
SELF-CONTAINED BREATHING APPARAT US.
Ventilation:GENERAL MECHANICAL VENTILATION IS ADEQUATE FOR NORMAL USE.
LOCAL EXHAUST IS PREFERRED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
IMPERVIOUS BOOTS, APRON, OR COVERALLS AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH AFTER HANDLING AND BEFORE EATING,
DRINKING OR SMOKING.
Supplemental Safety and Health
NITRIC ACID IS AN OXIDIER AND SHOULD NOT COME IN CONTACT WITH
CARTRIDGES AND CANISTERS THAT CONTAINS OXIDIZABLE MATERIALS, SUCH
AS ACTIVATED CHARCOAL. CANISTER-TYPE RESPIRATORS USING SORBENTS ARE
INEF FECTIVE.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:=122.2C, 252.F
Melt/Freeze Pt:=-42.C, -43.6F
Vapor Pres:(MM HG)48@20C(68F)
Vapor Density:(AIR=1)2.3
Spec Gravity:1.41
pH:1.0(0.1M SOLUT)
Solubility in Water:INFINITELY SOLUBLE
Appearance and Odor:COLORLESS TO YELLOWISH LIQUID - SUFFOCATION ACID
ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MOST SUBSTANCES, ESPECIALLY STRONG BASES, METALLIC POWDERS, CARBIDES,
HYDROGEN SULFIDE, TURPENTINE, AND COMBUSTIBLE ORGANICS
Stability Condition to Avoid:STABLE UNDER ORDINARY CONDITIONS OF USE
AND STORAGE. CONTAINERS MAY BURST WHEN HEATED.
Hazardous Decomposition Products:TOXIC VAPORS OF NITROGEN OXIDES AND
HYDROGEN NITRATE, CORROSIVE FUMES
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:ORAL (H\UMAN) LDL0: 430 MG/KG.
===================== Ecological Information =====================
Ecological:NO INFORMATION FOUND
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECOVERY OR
RECYCLING SHOULD BE HANDLED AS HAZARDOUS WASTE. DISPOSE OF WASTE IN
ACCORDANCE WITH LOCAL, STATE, AND FEDERAL LAWS AND REGULATIONS.
DISPOSE OF CONTAINER AND UN USED CONTENTS IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REQUIREMENTS.
===================== Regulatory Information =====================
SARA Title III Information:313 LIST: NITRIC ACID: RQ: 1000 LBS
Federal Regulatory Information:CERCLA RQ: 1000 LBS; LISTED ON TOXIC
SUBSTANCES CONTROL ACT (TSCA)
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AMBERLITE IRN-150 RESIN
CAGE:77902
CAGE:77902
============= Composition/Information on Ingredients =============
Ingred Name:ANION/CATION EXCHANGE RESIN.
Fraction by Wt: 35-50%
Other REC Limits:NONE ESTABLISHED
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 50-65%
Other REC Limits:NONE ESTABLISHED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ON EYE CONTACT, IT MAY CAUSE
IRRITATION.
Effects of Overexposure:MAY CAUSE IRRITATION ON EYE CONTACT.
Medical Cond Aggravated by Exposure:NONE STATED.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH EYES WITH LARGE AMOUNTS OF WATER AND
CONTINUE FOR AT LEAST 15 MINUTES. GET PROMPT MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, OR WATER SPRAY.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS
(PRESSURE-DEMAND, MSHA/NIOSH-APPROVED OR EQUIVALENT) AND FULL
PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:TOXIC COMBUSTION PRODUCTS MAY INCLUDE
ALKYLAMINES AND OXIDES OF SULFUR AND NITROGEN.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AND TRANSFER TO CONTAINERS FOR
RECOVERY OR DISPOSAL. FLOOR MAY BE SLIPPERY. USE CARE TO AVOID
FALLS.
Neutralizing Agent:NONE STATED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT AMBIENT TEMPERATURES. AVOID
REPEATED FREEZE-THAW CYCLES. GROUD ION EXCHANGE RESINS SHOULD BE
TREATED AS POTENTIAL EYE IRRITANT.
Other Precautions:A FINELY GROUD FORM OF A STRUCTURALLY RELATED STRONG
ACID CATION EXCHANGE RESIN PRODUCED SEVERE RABBIT EYE IRRITATION.
THE MAX. OPERATING TEMP. IS 60C/140F. FUNCTIONAL GROUP DESTRUCTION
& LOSS OF CAPA CITY WILL OCCUR ABOVE THIS TEMP.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE USUALLY REQUIRED FOR NORMAL OPERATION.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:NONE STATED.
Work Hygienic Practices:NONE STATED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:17
Vapor Density:< WATER
Spec Gravity:1.1-1.3
pH:5-9
Evaporation Rate & Reference:LESS THAN WATER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BEADS,
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH CONCENTRATED NITRIC ACID OR ANY OTHER STRONG
OXIDIZING AGENT AT ALL TIMES.
Stability Condition to Avoid:AVOID TEMPERATURES OVER 200C/392F.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD
STYRENE MONOMER, DIVINYLBENZENE, ALKYLAMINES AND OXIDES OF SULFUR
AND NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNUSED RESIN MAY BE INCINERATED OR LANDFILLED IN
FACILITIES MEETING LOCAL, STATE, AND FEDERAL REGULATIONS. FOR
CONTAMINATED RESIN, THE USER MUST DETERMINE THE HAZARD AND USE AN
APPROPRIATE DISPOSAL ME THOD.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL ALKYD SG BLUE 25053 ID 745506
Preparer's Name:W.A. ELLISON
CAGE:FO127
CAGE:FO127
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:MINERAL SPIRITS
(VP 2 MM HG @ 20 DEG C)
CAS:64475-85-0
RTECS #:PY8240000
OSHA PEL:500 PPM 2950 MG/CU.M
ACGIH TLV:100 PPM 525 MG/CU.M
Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9192
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:SILICA, CRYSTALLINE - FUSED
CAS:60676-86-0
RTECS #:VV7328000
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:VOC. ORGANIC CMPD 3.7 LB/GL LESS WATER & NPRS* 444 G/L
LESSWATER VOC 8.6 LB/GAL SOLIDS 1032 G/L SOLIDS CALCULATED.
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SWALLOWING: CAN CAUSE GASTROINTESTINAL
IRR/NAUSEA/VOMIT. ASPIRATION OF MAT'L MAYCAUSE CHEM PNEUMONITIS.
INHALATION: NOSE/THROAT IRRITA. HIGH CONCENTRATION MAY CAUSE
CENTRAL NERVOUS SYSTEM DEPRESSION CHAR BY
HEADACHES/DIZZINESS/NAUSEA/CONFUSION. EYE: MAY CAUSE EYE IRRITA.
SKIN: MAY CAUSE DEFATTING AND IRRITATION.
Explanation of Carcinogenicity:TITANIUM DIOXIDE IS NOT LISTED AS A
POTENTIAL CARCINOGEN BY THE NTP, IARC, OSHA OR A.C.G.I.H.
Effects of Overexposure:REPEATED EXPOSURE TO CRYSTALLINE SILICA MAY
CAUSE PNEUMOCONIOSIS. OCCUPATIONALOVEREXPOSURE TO SOLVENTS ASSO
W/PERM BRAIN/NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY
CONCENTRATING/INHALING CONT MA Y BE HARMFUL/FATAL.
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY CONDITIONS
MAY BE AGGRA- VATED BY EXPOSURE TO CRYSTALLINE SILICA.
======================= First Aid Measures =======================
First Aid:SWALLOWING: DO NOT INDUCE VOMITING/GET MED ATTN. INHALATION:
REMOVE TO FRESH AIRIF BREATHING HAS STOPPED GIVE CPR. GET MED ATTN.
EYE: FLUSH W/WATER FOR 15 MIN LIFTING UPPER/LOWER LIDS. GET MED
ATTN. SKIN: REMOVE CONTAMINATED CLOTHING.WASH AFFECTED AREA.
OBTAIN MED ATTN IF IRR'N PERSISTS. TREATMENT REQ FOR OVER-
EXPOSURE S/B DIRECTED AT THE CONTROL OF SYMPTOMS AND THE CLINICAL
CONDITIONS.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>102 F/38.89 C
Extinguishing Media:CLASS B FIRE EXTINGUISHERS TO EXTINGUISH FLAMMABLE
LIQUID FIRES. POLYMER FOAM IS PREFERRED FOR LARGE FIRES.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS. WATER
MAY BE INNEFECTIVE, BUT MAY BE USED TO PREVENT PRESSURE BUILD-UP.
IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS AND FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL IGNITION SOURCES. DIKE/CONTAIN SPILL
WITHINERT MAT'L. TRANSFER LIQ'S/ABSORBENT DIKING MAT'LIN COVERED
METAL CONT'S FOR RECOVERY/DISPOSAL. USEONLY NON-SPARKING TOOLS.
PREVENT CONTAM OF SEWERS/ STREAMS/GROUNDWATER W/SPILLED MAT'L/USED
ABSORBENT
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 95F. STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29CFR1910.106.
Other Precautions:DO NOT BREATHE SANDING DUST/OR REUSE EMPTY CONT. DO
NOT TAKE INTERN. CONT'ER S/BGROUNDED AND BONDED TO THE RECEIVING
CONTAINER. DO NOT WELD/BRAZE OR CUT CONT'R.NEVER USE PRESSURE TO
EMPTY. DRUM IS NOTA PRESSURE VESSEL. CLOSE AFTER EA USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WELL VENTILATED AREA-RESP NOT REQ. RESTRICTED
VENT-NIOSH CHEMICAL CARTRIDGE MAY BE REQ. IF SPRAYING, MECH
PREFILTER MAY BE REQ. IF TLV ARE EXCEEDED, USE A PROP FITTED
NIOSH/MSHA RESP W/APPROP PROTECTI ON FACTOR. SEE OSHA 29 CFR
1910.134.
Ventilation:PROVIDE DILUT/LOCAL EXH VENT TO KEEP CONCENT OF HAZ INGRID
BELOW EXPOSURE LMT STD. REMOVE PROD GEN-WELD/CUT/BRAZ OBJECT
Other Protective Equipment:NOT LIKELY TO BE NEEDED.
Work Hygienic Practices:WASH WITH SOAP AND WATER HANDS/FACE THROUGHLY
BEFORE EATING OR DRINKING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:280-388 F
Vapor Density:> THAN AIR
Evaporation Rate & Reference:SLOWER THAN EHTER
Percent Volatiles by Volume:58
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING,INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE AND
CARBON DIOXIDE.
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT SPARKS AND
FLAME.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE ONLY IN EPA PERMITTED FACILITY.
DISPOSEONLY IAW FED/STATE/LOCAL REGS. DO NOT INCINERATE CLOSED
CONTAINERS. OBSERVE PRECAUTIONS FOR DIS- POSAL OF FLAMMABLE
MAT'S. CONTAMINATED ABSORBENT MAY BE DISPOSED IN A HAZARDOUS
WASTE LANDFILL.
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.