text
stringlengths 307
13.1k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY NEEDED. USE AIR SUPPLIED MASK IN
VERY HIGH CONCENTRATIONS.
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION IS NORMALLY ADEQUATE.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
KEY1:J1. THIS IS PART C OF A 3-PART KIT. FOR PARTS A AND B, SEE PNI A
AND B, SAME NSN.
* Product Identification *
Product ID:CURE STABILIZER FOR MAG.RUB.INSP.,PART C
Kit Part:Y
Preparer's Name:P. MICHAEL PECK
* Composition/Information on Ingredients *
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE AND SKIN IRRITATION AND
DERMATITIS BY CONTACT. NOSE AND THROAT IRRITATION, HEADACHE AND
DIZZINESS BY INHALATION.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES:IRRITATION. SKIN:IRRITATION,DERMATITIS.
INHALATION:IRRITATION OF NOSE AND THROAT,HEADACHE,DIZZINESS.
Medical Cond Aggravated by Exposure:NONE NOTED.
* First Aid Measures *
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. SEE DOCTOR IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:CC
Autoignition Temp:Autoignition Temp Text:UNKNON
Lower Limits:2.6
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE AREA. WEAR
APPROPIATE PROTECTIVE CLOTHING AND EQUIPMENT. ABSORB IN INERT
ABSORBENT AND PLACE IN APPROPIATE DISPOSAL CONTAINER AND SEAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP AWAY FROM HEAT, IGNITION SOURCES AND INCOMPATIBLE
MATERIALS. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES
AND SKIN. USE WITH ADEQUATE VENTILATION.
* Physical/Chemical Properties *
HCC:F2
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, AVOID CATALYSTS SUCH AS BARIUM HYDROXIDE, AND
OTHER ALKALIES. AVOID SULFURIC ACID.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
INCOMPLETELY BURNED CARBON PRODUCTS.
* Disposal Considerations *
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
INCINERATE IN A FURNACE WHERE PERMITTED. DISPOSAL SHOULD BE MADE IN
ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:REQUIRED
Ventilation:LOCAL EXHAUST, VENT HOOD
Other Protective Equipment:LAB COAT
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
OSHA PEL:0.5 MG/CUM
Fraction by Wt: 1-5%
OSHA PEL:5 MG/CUM
ACGIH TLV:5.2 MG/CUM
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: SEVERE IRRITATION/BURNS OF
THE RESPIRATORY SYSTEM, PULMONARY EDEMA, LUNG INFLAMMATION, MAY BE
FATAL. SKIN/EYES: MAY CAUSE SEVERE IRRITATION/BURNS. INGESTION:
SEVERE BURNS, ULCERATION TO MO UTH, THROAT & STOMACH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNS, COUGHING, DIFFICULT
BREATHING, CHEST PAINS, INFLAMMATION, UNCONSCIOUSNESS, NAUSEA,
VOMITING
Medical Cond Aggravated by Exposure:NONE
* First Aid Measures *
First Aid:INGESTION: DON'T INDUCE VOMITING. IF CONSCIOUS, GIVE WATER,
MILK/MILK OF MAGNESIA. EYES/SKIN: IMMEDIATELY FLUSH W/PLENTY OF
* Fire Fighting Measures *
Extinguishing Media:USE APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR PROPER PROTECTIVE EQUIPMENT & SELF
CONTAINED BREATHING APPARATUS W/FULL FACEPIECE OPERATED IN POSITIVE
PRESSURE MODE.
* Accidental Release Measures *
Spill Release Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING. STOP
LEAK SAFELY W/O RISK. USE WATER SPRAY TO REDUCE VAPORS. TAKE UP
W/SAND/OTHER NON-COMBUSTIBLE ABSORBENT MATERIAL & PLACE INTO
CONTAINER FOR LATER DISPOSAL. FL USH AREA W/WATER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN CORROSION-PROOF AREA.
* Physical/Chemical Properties *
Spec Gravity:1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, YELLOW SOLUTION W/NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ORGANIC MATERIALS, STRONG REDUCING AGENTS
Hazardous Decomposition Products:OXIDES OF NITROGEN
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF 8-HOUR EXPOSURE LIMIT OR VALUE IS EXCEEDED
FOR ANY COMPONENT, USE A NIOSH/MSHA APPROVED RESPIRATOR, CONSULT
FOR RESPIRATORY REQUI REMENTS.
Ventilation:IF DRY-SANDING, PROVIDE SUFFICIENT MECHANICAL VENTILATION
TO MAINTAIN EXPOSURE BELOW PEL AND TLV.
Other Protective Equipment:PROVIDE EYEWASH AND IMPERVIOUS APRON IF BODY
CONTACT WITH PRODUCT MAY OCCUR.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
SOL IN H2O: FORMS AN ALKALINE DISPERSION WITH WATER. EXPLAN OF CARCIN:
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)
OSHA PEL:0.1 MG/M3 RDUST
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SILICATE, PORTLAND CEMENT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: WET CEMENT CAN DRY SKIN AND
CAUSE ALKALI BURNS. EXPOSURE TO DUST MAY RESULT IN BUILD-UP OF
MATERIAL IN EYES, EARS, NOSE AND MOUTH WHICH MAY CAUSE IRRITATION.
CHRONIC: INHAL OF DUST MAY RESULT I N PULMONARY AND RESPIRATORY
DAMAGE.
Explanation of Carcinogenicity:CRYSTALLINE SILICA-QUARTZ: IARC
REPORT ON (SUPP DATA)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ASTHMATIC CONDITIONS MAY WORSEN
FROM PROLONGED AND REPEATED EXPOSURE.
* First Aid Measures *
MINUTES. CONTACT A PHYSICIAN IMMEDIATELY. SKIN: WASH WITH SOAP AND
WATER. INHAL: REMOVE TO FRESH AIR. CONTACT PHYSICIAN IMMEDIATELY.
INGEST: DO N OT INDUCE VOMITING. CONTACT PHYSICIAN OR REGIONAL
POISON CONTROL CENTER.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER SPRAY TO COOL EXPOSED SURFACES.
Unusual Fire/Explosion Hazard:NONE KNOWN.
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT MATERIAL OR SCRAPE UP DRIED
MATERIAL AND PLACE INTO CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:2.3-2.4(H2O=1)
Solubility in Water:SUPP DATA
Appearance and Odor:SANDY GRAY OR WHITE FREE-FLOWING POWDER
Percent Volatiles by Volume:<1
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:EXCESSIVE HEAT AND FREEZING.
Hazardous Decomposition Products:NONE KNOWN.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF ACCDG TO FEDERAL, STATE AND LOCAL
STANDARDS. DO NOT REUSE EMPTY CONTAINERS. THIS PRODUCT IS
NON-HAZARDOUS ACCORDING TO U.S. EPA'S HAZARDOUS WASTE MANAGEMENT
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPRVD SUPPLIED-AIR RESP REC WHERE
TLV EXCEEDED.ODOR NOT INDICATIVE OF EXPOS (AIR-PURIFYING EQUIP NOT
REC).EQUIP TYPE DEPENDS ON CONTAMINANT TYPE/CONC.SELECT IAW
FIRE-FIGHTS.
Ventilation:GENERAL VENT SHOULD BE ADEQUATE FOR NORM USE.USE FORCED
VENT (LOC EXHAUST) WHERE TLV MAY BE EXCEEDED.
Other Protective Equipment:PROTECTIVE CLOTHING TO AVOID PRLNG/RPTD SKIN
CONT.SUITABLE WASHING & EYE FLUSHING FACILITIES AVAILABLE IN WORK
AREA.
Work Hygienic Practices:CONTAMINATED CLOTHING SHOULD BE REMOVED AND
LAUNDERED BEFORE RE-USE.
Supplemental Safety and Health
MORE-NAUS,VOMIT,HDCH,INSOM,UNSTEADY GAIT,VISUAL EFFECTS.FIRST AID
PROC:INHAL:REM OVE TO FRESH AIR.IF BRTHG DFCLT,ADMIN OXYGEN.IF
BRTHG STOPS,ADMIN ARTF RESP.GET MED ATTN IMMED.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
Other REC Limits:N/K
Ingred Name:CARBON DIOXIDE
Fraction by Wt: 1-5%
Other REC Limits:N/K
Ingred Name:PROPYLENE GLYCOL
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRLNG & WIDESPREAD SKIN CONT:POSS
BLINDNESS.MASSIVE OVERDOSES:INJURY T O LIVER,KIDNEY AND HEART
MUSCLE HAVE BEEN DESCRIBED.MODERATE QUANTITIES OF
METHANOL-METABOLIC ACIDOSIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:DISCOMFORT,REDNESS,SWELLING OF
CONJUNCTIVA,CORNEAL INJURY.SKIN:PRLNG
CONT-REDNESS,DEFAT.ABSORPTION:POSS HARMFUL.INGEST:NAUS,ABDOM
PAIN,VOMIT,CNS DEPRESS,COMA,DEATH.VISUAL EFFECTS,POSS COMPLETE BL
INDNESS.METABOLIC ACIDOSIS.INHAL:DIZZ,DROW,VISUAL
DISTURB,TINGLING,NUMBNESS,SHOOTING PAIN IN HANDS & FOREARMS.(SEE
SUPP)
Medical Cond Aggravated by Exposure:DUE TO THE DEFATTING PROPERTIES OF
METHANOL,AN EXISTING SKIN CONDITION (SUCH AS ECZEMA) MAY BE
AGGRAVATED.
* First Aid Measures *
First Aid:EYES:IMMED FLUSH W/ LOTS OF H*2O,IN STEADY STREAM FOR AT
CLTHG.IMMED WASH W/ SOAP & LOTS OF H*2O.IF SYMP PERSIST,GET MED
ATTN.INGEST:GIVE 2GLASSES H*2O & INDUCE VOMIT IMMED.NEVER GIVE
ANYTHING BY MOUTH TO UNCON PERSON.IMMED CALL MD,EMER ROOM OR POIS
CTL CTR.ETHANOL IS EFTIVE ANTIDOTE.TAKE PATIENT & CONTR TO EMER MED
FACILITY.(SEE SUPP)
* Fire Fighting Measures *
Flash Point Method:TOC
Upper Limits:6.7%
Extinguishing Media:FOAM,ALCOHOL FOAM,CARBON DIOXIDE OR DRY CHEMICAL
FOR SMALL FIRE.WATER FOG FOR LARGE FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
EXPOSED TO HEAT MAY RUPTURE.HAZ COMBUST PROD:CO & CO*2.
* Accidental Release Measures *
Spill Release Procedures:WEAR SUITABLE PERSONAL PROTECTIVE
EQUIPMENT.REMOVE ALL SOURCES OF IGNITION AND COLLECT FOR DISPOSAL
IN A FLAMMABLE WASTE CONTAINER.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:DANGER:CONTENTS UNDER PRESSURE.DO NOT
GOVERNMENTAL REGULATIONS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.DO NOT INGEST-MAY BE
FATAL OR CAUSE BLINDNESS.AVOID EYE AND SKIN CONTACT.DO NOT INHALE
VAPOR,USE IN WELL VENTILATED AREA.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Density:1 (AIR=1)
Evaporation Rate & Reference:6 (BUTYL ACETATE=1)
Appearance and Odor:CLEAR,COLORLESS LIQUID WITH ALCOHOL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:SPARKS,HEAT,OPEN FLAMES.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON
MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISP MUST BE IAW FEDERAL,STATE & LOCAL
REGULATIONS .WASTE MATERIAL IS A RCRA HAZARDOUS WASTE DUE TO
IGNITABILITY.INCINERATION OR LAND FILLING SHOULD BE CARRIED OUT IAW
REPORTING.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Other Protective Equipment:SAFETY SHOES, SAFETY SHOWER.
Supplemental Safety and Health
FOR HANDLING & STORAGE RECOMMENDATIONS, CONSULT COMPRESSED GAS
FIRMLY SECURED TO PREVENT FALLING. VALVE PROTECTION CAPS & VALVE
OUTL ET THREADED PLUGS MUST REMAIN IN PLACE UNLESS CNTNR IS SECURED
WITH VALVE OUTLET PIPED TO USE POINT.
* Product Identification *
Product ID:OXYGEN
* Composition/Information on Ingredients *
Ingred Name:OXYGEN
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
MOLAR PERCENT) CAUSES SYMPTOMS OF HYPEROXIA WHICH INCLUDE CRAMPS,
NAUSEA, DIZZINESS, HYPOTHERMIA, AMBYLOPIA, RESPIRATORY
DIFFICULTIES, BRADYCARDIA, FAINTING SPELLS, & CONVULSIONS CAPABLE
OF LEADING TO DEATH. FOR ADDITIONAL INFO ON HYPEROXIA, SEE
* First Aid Measures *
First Aid:PROMPT MEDICAL ATTENTION MANDATORY. EXTREME FIRE HAZARD
ASSOCIATED W/OXYGEN-RICH ATMOSPHERE. ASSIST CONSCIOUS PERSONS TO
UNCONTAMINATED AREA & BREATHE FRESH AIR. KEEP WARM & QUIET. INFORM
PHYSICIAN TH AT VICTIM EXPERIENCING (HAS EXPERIENCED) HYPEROXIA.
MOVE UNCONSCIOUS PERSONS UNCONTAMINATED AREA & GIVE ASSISTED
RESPIRATION. CONTINUED TREATMENT SHOULD BE SYMPTOMATIC &
SUPPORTIVE.
* Fire Fighting Measures *
Extinguishing Media:COPIOUS QUANTITIES OF WATER FOR FIRES WITH OXYGEN
AS THE OXIDIZER.
Fire Fighting Procedures:IF POSSIBLE, STOP THE FLOW OF OXYGEN WHICH IS
SUPPORTING THE FIRE.
Unusual Fire/Explosion Hazard:OXYGEN ACCELERATES COMBUSTION. AVOID
CONTACT W/FLAMMABLE MATERIALS. SOME MATERIALS, NOT FLAMMABLE IN
AIR, WILL BURN IN PURE OXYGEN/OXYGEN ENRICHED ATMOSPHERE.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE ALL PERSONNEL FROM AFFECTED AREA. USE
PROTECTIVE EQUIP. IF LEAK IS IN USER'S EQUIP, BE SURE TO PURGE
PIPING WITH INERT GAS PRIOR TO ATTEMPTING REPAIRS. IF LEAK IN
NUMBER.
*Handling and Storage *
Handling and Storage Precautions:USE SUITABLE HAND TRUCK FOR CYLINDER
MOVEMENT. USE PRESSURE REDUCING REGULATOR WHEN CONNECTING CYLINDER
TO LOWER PRESSURE. DO NOT HEAT CYLINDER.
Other Precautions:PROTECT CYLINDER FROM DAMAGE. STORE IN
COOL,DRY,VENTED AREA & AWAY FROM CYLINDERS CONTAINING FLAMMABLE
PREVENT FULL CYLINDERS BEING S TORED FOR EXCESSIVE PERIODS OF TIME.
* Physical/Chemical Properties *
Solubility in Water:SLIGHTLY
Appearance and Odor:COLORLESS, ODORLESS GAS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALL FLAMMABLE MATERIALS
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:DON'T DISPOSE OF WASTE/UNUSED QUANTITIES. RETURN
IN SHIPPING CONTAINER PROPERLY LABLED, W/VALVE OUTLET PLUGS/CAPS
SECURED & VALVE PROTECTION CAP IN PLACE TO SUPPLIER. EMERGENCY
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A NIOSH APPROVED AIR PURIFYING DUST OR MIST
Ventilation:USE ADEQ GENERAL OR LOCAL EXHAUST VENT TO KEEP AIRBORNE
CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
FACESHIELD .
Other Protective Equipment:EMERGENCY EYE WASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA ). WEAR APPROPRIATE PROTECTIVE CLOTHING TO
PREVENT SKIN EXPOSURE.
Supplemental Safety and Health
MATLS TO AVOID: CINNAMALDEHYDE OR ZINC; & REACTS EXPLOSIVELY W/MIXTURE
OF CHLOROFORM & METHANE. CORR TO METALS SUCH AS ALUMINUM, TIN &
ZINC AS WELL AS TO ALLOYS SUCH AS STEEL & MAY CAUSE FORMATION OF
FLAMMABLE HYDROGEN GAS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM HYDROXIDE
OSHA PEL:2 MG/M3
ACGIH STEL:C2 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: CAUSES SEVERE EYE BURNS. SKIN:
CAUSES SKIN BURNS. MAY CAUSE DEEP, PENETRATING ULCERS OF THE SKIN.
INGESTION: HARMFUL IF SWALLOWED. CAUSES GASTROINTESTINAL TRACT
BURNS. CAUSES SEVERE PAIN, NAUSEA,VOMITING, DIARRHEA AND SHOCK.
INHALATION: IRRITATION MAY LEAD TO CHEMICAL PNEUMONITIS AND
PULMONARY EDEMA. CAUSES SEVERE IRRITATION OF UPPER RESPIRATORY
TRACT WITH COUGHING, BURNS, BREATHING DIFFICUL TY AND POSSIBLE
COMA. CHRONIC: PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE
DERMATITIS. TARGET ORGANS: NONE.
Effects of Overexposure:SEE HEALTH HAZARDS.
* First Aid Measures *
OCCASIONALLY LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN:
GET MED AID IMMED. IMMED FLUSH SKIN W/PLENTY OF SOAP & WATER FOR AT
CLTHG IN A MANNER WHICH LIMITS FURTHER EXPOS. INGEST: DO NOT INDUCE
VOMIT. IF VICTIM IS UNCON & ALERT, GIVE 2-4 CUPFULS OF MILK OR
WATER. N EVER GIVE ANYTHING BY MOUTH TO AN UNCON PERSON. GET MED
AID IMMED. INHAL: REMOVE FROM EXPOS TO FRESH AIR IMMED. IF NOT
BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. GET MED AID.
NOTES TO MD: TREAT SYMPTOMATICALLY & SUPPORTIVELY.
* Fire Fighting Measures *
Flash Point:NOT AVAIL
Autoignition Temp:Autoignition Temp Text:N/AV
Lower Limits:NOT AVAIL
Upper Limits:NOT AVAIL
Extinguishing Media:FOR SMALL FIRES, USE DRY CHEMICAL, CARBON DIOXIDE,
WATER SPRAY OR ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER WITH CAUTION AND IN FLOODING AMOUNTS.
Unusual Fire/Explosion Hazard:CONTACT WITH MOISTURE OR WATER MAY
GENERATE SUFFICIENT HEAT TO IGNITE NEARBY COMBUSTIBLE MATERIALS.
(ESTIMATED) HEALTH: 3; FLAMMABILITY: 0; REACTIVITY: 1.
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT AS
INDICATED. VACUUM OR SWEEP UP MATERIAL AND PLACE INTO A SUITABLE
DISPOSAL CONTAINER. AVOID GENERATING DUSTY CONDITIONS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
AREA AWAY FROM INCOMPATIBLE SUBSTANCES. KEEP AWAY FROM STRONG
ACIDS. KEEP AWAY FROM WATER. KEEP AWAY FROM METALS. KEEP AWAY FROM
FLAMMABLE LIQUIDS. KEEP AWAY FROM ORGANIC HALOGENS. CORROSIVES
AREA. HYGROSCOPIC.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. USE WITH ADEQUATE
VENTILATION. DO NOT ALLOW WATER TO GET INTO THE CONTAINER BECAUSE
OF VIOLENT REACTION. DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. DO
NOT INGEST OR I NHALE.
* Physical/Chemical Properties *
Decomp Temp:Decomp Text:NOT AVAIL
Vapor Density:NOT AVAIL
pH:NOT AVAIL
Viscosity:NOT AVAILABLE
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:1 G/0.9 ML WATER
Appearance and Odor:WHITE SOLID; ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
GENERATES LG AMTS OF HEAT WHEN IN CONTACT W/WATER & MAY STEAM &
SPLATTER. REACTS W/MINERAL ACIDS TO FORM CORRESPONDING SALTS;
REACTS W/WEAK ACIDS, GASES LIKE HYDROGEN SULFIDE, SULFUR DIOXIDE &
CARBON DIOXIDE; IGNITED WHEN I
Stability Condition to Avoid:INCOMPATIBLE MATERIALS, MOISTURE, CONTACT
WITH WATER, ACIDS.
Hazardous Decomposition Products:TOXIC FUMES OF SODIUM OXIDE, SODIUM
PEROXIDE FUMES.
* Toxicological Information*
Toxicological Information:CARCINOGENICITY: SODIUM HYDROXIDE - NOT
LISTED BY ACGIH, IARC, NIOSH, NTP OR OSHA. EPIDEMIOLOGY: NO INFO
REPORTED. TERATOGENICITY: NO INFO REPORTED. REPRODUCTIVE EFTS: NO
INFO REPORTED. NEUROTOXICITY: NO INFO REPORTED. MUTAGENICITY:
MUTATION DATA REPORTED. OTHER STUDIES: NO INFO REPORTED.
* Ecological Information *
CHEM IS NOT MOBILE IN SOLID FORM, ALTHOUGH IT ABSORBS MOISTURE VERY
EASILY. ONCE LIQUID, SODIUM HYDROXIDE LEACHES RAPIDLY INTO THE
SOIL, POSSIBLY CONTAMINATING WATER SOURCES. PHYSICAL/CHEMICAL: NO
INFO FOUND. OTHER: NO INFO FOUND.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN MANNER CONSISTENT W/FEDERAL, STATE
& LOCAL REGULATIONS. RCRA D-SERIES MAXIMUM CONCENTRATION OF
CONTAMINANTS: NONE LISTED. RCRA D-SERIES CHRONIC TOXICITY REFERENCE
LEVELS: NONE LISTED. RC RA F-SERIES: NONE LISTED. RCRA P-SERIES:
NONE LISTED. RCRA U-SERIES: NONE LISTED.
* MSDS Transport Information *
Transport Information:US DOT: SHIPPING NAME: SODIUM HYDROXIDE, SOLID.
SHIPPING NAME: SODIUM HYDROXIDE, SOLID. HAZARD CLASS: 8. UN NUMBER:
RID/ADR: SHIPPING NAME: SODIUM HYDROXIDE, SOLID. DANGEROUS GOODS
ECOLOGICAL INFO (CONT): KINGDOM: TWA 2 MG/M3; STEL 2 MG/M3. OEL IN
BULGARIA, COLOMBIA CHECK ACGIH TLV. C ONTACT NEHC FOR ADDITIONAL
INFO
* Regulatory Information *
DOES NOT CNTN ANY HAZ AIR POLLUTANTS. THIS MATL DOES NOT CNTN ANY
CLASS 1 OZONE DEPLETORS. THIS MATL DOES NOT CNTN ANY CLASS 2 OZONE
SUBSTANCE UNDER CWA. NONE OF CHEMS IN PROD ARE LISTED AS PRIORITY
POLLUTANTS UNDER CWA. NONE OF CHEMS IN PROD ARE LISTED AS TOX
POLLUTANTS UNDER CWA. OSHA: NONE OF CHEMS IN PROD CONSIDERED
HIGHLY HAZ BY OSHA.
TSCA INVENTORY. HEALTH & SAFETY REPORTING LIST: NONE OF THE
CHEMICALS IN THIS PRODUCT ARE UNDER A CHEMICAL TEST RULE. SECTION
SIGNIFICANT NEW USE RULE: NONE OF THE CHEMICALS IN THIS MATERIAL
HAVE A SNUR UNDER TSCA.
State Regulatory Information:SODIUM HYDROXIDE CAN BE FOUND ON THE
FOLLOWING STATE RIGHT TO KNOW LISTS: CALIFORNIA, NEW JERSEY,
FLORIDA, PENNSYLVANIA, MINNESOTA, MASSACHUSETTS. CALIFORNIA NO
SIGNIFICANT RISK LEVEL: NONE OF THE CHE MICALS IN THIS PRODUCT ARE
LISTED.
| 1 | gloves_mandatory |
Control Measures
*
Cage: 0FTT5
*
Preparer Co. when other than Responsible Party Co.
*
Cage: 0FTT5
*
Contractor Summary
*
Cage: 0FTT5
*
Item Description Information
*
Item Manager: GSA
Item Name: ENAMEL
Unit of Issue: PT
UI Container Qty: 0
*
Ingredients
*
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 5 PPM
------------------------------
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE RECOMMENDED
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE: IRRIT. SKIN: IRRIT. INHAL: RESPIRATORY TRACT AND
THROAT IRRIT, HEADACHE, NAUSEA, VOMIT, HARMFUL, FATAL, BRAIN/NS DAMAGE,
ANESTHETIC, LIGHTHEADED, STAGGERING GAIT, GIDDY, NAUSEA. INGEST: HARMFUL.
Medical Cond Aggravated By Exposure: RESPIRATORY AILMENTS
WASH CLOTHES BEFORE REUSE. INHAL: REMOVE TO FRESH AIR. ARTIFICIAL RESPIRATION
IF NEEDED. INGEST: DONT INDUCE VOMIT. IN ALL CASES, GET IMME D MED AID.
*
Handling and Disposal
*
Spill Release Procedures: REMOVE IGNIT SOURCES. VENTILATE AREA. MOP SPILL
W/INERT ABSORBENT. AVOID BREATHING VAPORS.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE AND LOCAL
SUN MAY CAUSE CAN TO BURST. DISCARD EMPTY CAN IN TRASH PICK-UP. DONT PLAC E
IN HOME TRASH COMPACTOR.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. CAUTION:
Other Precautions: USE W/GOOD VENTILATION. READ ENTIRE LABEL BEFORE USING.
FOLLOW ALL LABEL DIRECTIONS.
*
Fire and Explosion Hazard Information
*
Lower Limits: 2.2
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY.
AVOID SPREADING ANY BURNING LIQUID W/WATER SPRAY.
Fire Fighting Procedures: WATER MAY BE INEFFCTIVE. USE WATER TO KEEP CONTAINERS
COOL. USE SCBA. USE SHIELDING TO PROTECT AGAINST BURSTING, RUPTURING OR
VENTING OF CONTAINERS.
CONTAINERS MAY VENT, RUPTURE OR BURST. AEROSOL CONTAINERS: DONT EXPOSE TO
*
*
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
Ventilation: LOCAL EXHAUST PREFERRED. MECHANICAL (GENERAL) ACCEPTABLE AT POINT
OF MIST OR SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN, EYEWASH
STATION.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DONT EAT, DRINK OR SMOKE
WHILE USING PRODUCT.
*
Physical/Chemical Properties
*
B.P. Text: NA
M.P/F.P Text: NA
Decomp Text: NA
PH: NA
Viscosity: NA
Solubility in Water: INSOLUBLE
Appearance and Odor: WHITE PAINT
Corrosion Rate: NA
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT
Materials To Avoid: NA
Hazardous Decomposition Products: CARBON MONOXIDE
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NA
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: PT
Container QTY: 0
*
Detail DOT Information
*
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Bulk Pack: NONE
Vessel Stow Req: A
*
Detail IMO Information
*
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
*
Detail IATA Information
*
IATA PSN Code: ALS
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
*
Detail AFI Information
*
AFI PSN Code: ALR
AFI Symbols: *
AFI Proper Shipping Name: AEROSOLS, FLAMMABLE, N.O.S.
AFI PSN Modifier: (EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.1
Special Provisions: P4
Back Pack Reference: A6.3
*
HAZCOM Label
*
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Label Required IND: Y
Status Code: A
Origination Code: G
Hazard And Precautions: EYE: IRRIT. SKIN: IRRIT. INHAL: RESPIRATORY TRACT AND
THROAT IRRIT, HEADACHE, NAUSEA, VOMIT, HARMFUL, FATAL, BRAIN/NS DAMAGE,
ANESTHETIC, LIGHTHEADED, STAGGERING GAIT, GIDDY, NAUSEA. INGEST: HARMFUL.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
Product ID:TRIS(2,2'-BIPYRIDYL)RUTHENIUM(II)CHLORIDE (
* Composition/Information on Ingredients *
Ingred Name:TRIS(2,2'-BIPYRIDYL)RUTHENIUM(II) CHLORIDE HEXAHYDRATE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES WITH COPIOUS
IMMEDIATELY WASH SKIN WITH SOAP AND COPIOUS AMOUNTS OF WATER. IF
INHALED, REMOVE T O FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. CALL MD. WASH
CONTAM CLOTHING BEFORE REUSE. INGEST: CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER SPRAY. CO*2, DRY CHEMICAL POWDER, ALCOHOL OR
POLYMER FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT . PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
THERMAL DECOMP PRODS MAY INCLUDE HCL AND PHOSGENE .
* Accidental Release Measures *
Spill Release Procedures:WEAR NIOSH/MSHA APPRVD RESPIRATOR, CHEM SAFETY
HOLD FOR WASTE DISP. AVOID RAISING DUST. VENT AREA & WASH SPILL
SITE AFTER MATL PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID BREATHING DUST. KEEP CONTAINER
CLOSED. LIGHT SENSITIVE. STORE IN A COOL DRY PLACE.
Other Precautions:AVOID CONT W/EYES, SKIN & CLOTHING. NO SMOKING IN
AREA OF USE. DO NOT USE IN GENERAL VICINITY OF ARC WELDING, OPEN
FLAMES OR HOT SURF. HEAT AND/OR UV RADIATION MAY CAUSE THE
FORMATION OF HCL AND/OR PH OSGENE .
* Physical/Chemical Properties *
HCC:N1
Appearance and Odor:RED-ORANGE POWDER.
* Stability and Reactivity Data *
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:MAY DISCOLOR ON EXPOSURE TO LIGHT.
Hazardous Decomposition Products:TOXIC FUMES OF: CO, CO*2, NO*X,
HYDROGEN CHLORIDE GAS. PHOSGENE .
* Disposal Considerations *
Waste Disposal Methods:CATALYSTS AND EXPENSIVE METALS SHOULD BE
RECOVERED FOR REUSE OR RECYCLING. OBSERVE ALL FEDERAL, STATE, AND
LOCAL LAWS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF WORKPLACE EXPOS LIM(S) OF PROD/ANY COMPONENT
IS EXCEEDED, A NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN
ABSENCE OF PROPER ENVIRON CTL. OSHA REGS ALSO PERMIT OTHER
NIOSH/MSHA RESP (NEGATIVE PR ESS TYPE) UNDER SPECIFIED (SUPP DATA)
Ventilation:MATL MAY BE HNDLD/TRANSFERRED IN AN APPRVD FUME HOOD/W/
EQUIVALENT VENT.
Other Protective Equipment:IMPERVIOUS PROT CLTHNG SHOULD BE WORN TO
PREVENT SKIN CNTCT. ANSI APPRVD EYE WASH & SFTY EQUIP SHOULD BE
READILY AVAIL.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
MATLS TO AVOID: ALDEHYDES AND UNSATURATED ORGANICS. RESP PROT: CNDTNS
(SEE YOUR SFTY EQUIP SUPPLIER). ENGINEERING &/ OR ADMINISTRATIVE
GGLES WITH FULL LENGTH FACESHIELD .
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM HYDROXIDE
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: EXTREMELY TOXIC AND
CORROSIVE. CAUSES SEVERE BURNS ON CONTACT WITH ANY BODY TISSUE
VAPOR IRRITATING TO EYES AND RESPIRATORY PASSAGES. TESTS ON LAB
ANIMALS INDICATE MATERIAL MAY PRODUCE ADVERSE MUTAGENIC EFTS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:DATA NOT AVAILABLE.
* First Aid Measures *
First Aid:GET MED ASSIST FOR ALL CASES OF OVEREXP. SKIN: IMMED FLUSH
THORO W/LG AMTS OF WATER. REMOVE CONTAMINATED CLOTHING AND WASH
MINUTES. INH AL: REMOVE TO FRESH AIR; GIVE ARTF RESPIF BREATHING
HAS STOPPED. INGEST: DO NOT INDUCE VOMITING; IF CONSCIOUS, GIVE
WATER FREELY AND GET MED ATTN.
* Fire Fighting Measures *
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:WATER FOG (DO NOT SPLATTER OR SPLASH THIS
MATERIAL).
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCES HIGHLY
TOXIC FUMES.
* Accidental Release Measures *
Spill Release Procedures:EVAC AREA OF ALL UNNEC PERS. WEAR SUITABLE
PROT EQUIP. ELIM ANY IGNIT SOURCES UNTIL AREA IS DETERMINED TO BE
FREE FROM EXPLO/FIRE HAZS. CNTN REL & ELIM ITS SOURCE, IF THIS CAN
BE DONE W/OUT RISK. TAKE UP & CONTAINERIZE FOR PROPER DISP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A DRY AREA AWAY FROM ACIDS,
METALS, ORG PEROXIDES & EASILY IGNITABLE MATLS. KEEP CONTR TIGHTLY
CLSD. DO NOT BREATHE DUST/VAP.
Other Precautions:DO NOT GET IN EYES, ON SKIN/ON CLTHG. RETAINED
RESIDUE MAY MAKE EMPTY CONTAINERS HAZARDOUS; USE CAUTION!
* Physical/Chemical Properties *
HCC:C2
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE ODORLESS DELIQUESCENT PELLETS/FLAKES
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, ACIDS, COMMON METALS & THEIR ALLOYS; ACIDS & THEIR ANHYDRIDES;
EASILY OXIDIZABLE CMPDS; INCL EXPLOS, (SUPP DATA)
Stability Condition to Avoid:MOISTURE.
Hazardous Decomposition Products:IN CONTACT WITH SOME METALS, HYDROGEN
GAS IS GENERATED.
* Disposal Considerations *
Waste Disposal Methods:COMPLY WITH FEDERAL, STATE, AND LOCAL
REGULATIONS ON REPORTING RELEASES. REFER TO REGULATORY INFORMATION
FOR REPORTABLE QTY AND OTHER REGULATORY DATA. EPA WASTE NUMBER:
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR
W/ORGANIC VAPOR CARTRIDGE/CANISTER MAY BE PERMISSIBLE WHERE
CONCENTRATIONS EXCEED EXPOSURE LIMITS.
Ventilation:USE VENTILATION THAT IS ADEQUATE TO KEEP EMPLOYEE EXPOSURE
TO AIRBORNE CONCENTRATIONS BELOW EXPOSURE LIMITS.
Other Protective Equipment:IMPERVIOUS CLOTHING, APRON, BOOTS, WHOLE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
ML/KG FOR AN AVERAGE ADULT. UNUSUAL FIRE CONT'D: FLAMMABLE LIQ UID.
VAPORS FORM EXPLOSIVE MIXTURE W/AIR &/>THAN AIR & TRAVEL IGNITION
SOURCES & FLASH BACK.
* Product Identification *
Product ID:METHYL METHACRYLATE - INHIBITED
Preparer's Name:F M LOGULLO
* Composition/Information on Ingredients *
Ingred Name:METHYL METHACRYLATE, (MONOMER)
Ingred Name:SUBSTITUTED PHENOL POLYMERIZATION INHIBITORS
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. PERMEATION MAY
OCCUR. EYES: IRRITATION & POSSIBLE CORNEAL DAMAGE. INHALATION:
NOSE, THROAT & LUNG IRRITATION. TEMPORARY SENSORY NERVOUS SYSTEM
EFFECTS. COMPOUND MAY CAUSE SKIN SENSIT IZATION IN SUSCEPTIBLE
HUMANS. INDIVIDUALS W/PREEXISTING DISEASES OF THE LUNGS MAY HAVE
INCREASED SUSCEPTIBILITY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DISCOMFORT, TEARING, BLURRED
VISION, HEADACHE, NAUSEA, WEAKNESS, COUGH, SHORTNESS OF BREATH.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
SKIN: IMMEDIATELY WASH W/SOAP & WATER. EYES: FLUSH W/PLENTY OF
GIVE 2 GLASS ES OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. NOTE TO PHYSICIAN: ACTIVATED CHARCOAL MIXTURE
MAY BE ADMINISTERED. (SEE SUPP)
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.7
Upper Limits:8.2
Extinguishing Media:FOAM, DRY CHEMICAL, CO2, WATER SPRAY (BY TRAINED
PERSONNEL).
Fire Fighting Procedures:KEEP UPWIND. WEAR SCBA & FULL PROTECTIVE
EQUIPMENT. COOL TANK/CONTAINER W/WATER SPRAY. FIGHT FROM DISTANCE,
HEAT MAY RUPTURE CONTAINERS.
Unusual Fire/Explosion Hazard:VAPORS ARE UNINHIBITED & MAY FORM
POLYMERS IN VENTS/FLAME ARRESTERS, RESULTING IN STOPPAGE OF VENTS.
* Accidental Release Measures *
Spill Release Procedures:USE APPROPRIATE PROTECTIVE EQUIPMENT. EVACUATE
& VENTILATE AERA. USE SCBA. REMOVE IGNITION SOURCES. DIKE, PREVENT
MATERIAL FROM ENTERING SEWERS & OTHER LOW AREAS. SOAK UP W/SAWDUST,
SAND, OIL DRY/OTHE R ABSORBENT MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER IN COOL PLACE. DON'T
EXPOSE TO DIRECT SUNLIGHT. STORE IN WELL-VENTILATED AREA. KEEP
CONTAINER TIGHTLY CLOSED.
Other Precautions:MAINTAIN AIR SPACE INSIDE STORAGE CONTAINERS. CHECK
INHIBITOR LEVELS AFTER 3 MONTHS & RETURN TO ORIGINAL LEVEL. CLOSE
CONTAINER AFTER EACH USE. GROUND CONTAINER WHEN POURING. KEEP FROM
HEAT, SPARKS & FLAMES.
* Physical/Chemical Properties *
Evaporation Rate & Reference:(BU AC =1): 3
Solubility in Water:1.6 WT%
Appearance and Odor:ACRID ACRYLIC COLORLESS LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING & REDUCING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, FLAME, IMPACT,
FRICTION/ELECTRICITY.
Hazardous Decomposition Products:CO, CO2, SMOKE.
Conditions to Avoid Polymerization:EXCESSIVE HEAT, STORAGE IN ABSENCE
OF INHIBITOR & INADVERTENT ADDITION OF CATALYST.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T FLUSH TO SURFACE WATER/SANITARY SEWER SYSTEM.
INCINERATE IAW/FEDERAL, STATE/PROVINCIAL & LOCAL REQUIREMENTS.
| 1 | gloves_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
------------------------------
------------------------------
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
EMERGENCY AND OTHER CONDITIONS WHERE SHORT
-----------------------------
PRESSURE SCBA.
-----------------------------
ONLY EXPLOSION-PROOF EQUIPMENT.
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: INHAL: SEV OVEREXP MAY RSLT IN NAUS, DIZZ, HDCH.
CAN CAUSE DROW, IRRIT OF EYES & NASAL PASSAGES. SKIN: IRRIT. LIQ CONT MAY
REMOVE NATURAL SKIN OILS RSLTG IN SKIN IRRIT. DERM MAY OCCUR W/PRLNG C ONT.
SKIN ABSORPTION: PRLNG/WIDESPREAD EXPOS MAY RSLT IN ABSORPTION OF HARMFUL
AMTS OF MATL. EYES: (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: OVEREXP MAY RSLT IN SEV EYE
INJURY W/CORNEAL/CONJUNCTIVAL INFLAMM ON CONT W/LIQ. VAPS SLIGHTLY
UNCOMFORTABLE. INGEST: MOD TOX. MAY CAUSE NAUS, VOMIT, DIARR. MAY CAUSE
MENTAL SLUGGISHNESS. CH RONIC: SYMP OF RESP TRACT IRRIT & DMG TO RESP
Medical Cond Aggravated By Exposure: INDIVIDUALS WITH PREEXISTING DISEASES OF
THE EYES, SKIN OR RESPIRATORY SYSTEM MAY HAVE INCREASED SUSCEPTIBILITY TO THE
TOXICITY OF EXCESSIVE EXPOSURE.
First Aid: INHAL: REMOVE TO FRESH AIR & IF BRTHG STOPPED, GIVE ARTF RESP.
IF BRTHG IS DFCLT, GIVE OXYGEN. CALL MD. EYES: FLUSH W/PLENTY OF WATER FOR AT
INGEST: GIVE 1 0R 2 GLASSES OF WATER/MILK. DO NOT INDUCE VOMIT. CALL MD/POIS
CTL CTR IMMED.
*
Handling and Disposal
*
Spill Release Procedures: ELIMINATE ALL IGNIT SOURCES. AVOID BRTHG OF VAPS.
KEEP LIQ OUT OF EYES. FLUSH W/LARGE AMTS OF WATER. CONTAIN LIQ W/SAND/EARTH.
ABSORB W/SAND/NON-FLAMM ABSORB MATL & TRANSFER INTO STEEL DRUMS FOR RECOV
ERY/DISP. PREVENT LIQ FROM ENTERING DRAINS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: FOLLOW LOC, STATE & FED REGS. CONSULT DISP EXPERT.
CAN BE DISP OF BY INCIN. EXCESS QTYS SHOULD NOT BE PERMITTED TO ENTER DRAINS.
FROM HEAT, SPARKS, OPEN FLAME & OTHER SOURCES OF IGNIT. AVOID PRLNG BRTHG
OF VAP. USE W/ADEQ VENT.
Other Precautions: AVOID CONT W/EYES, SKIN & CLTHG. TRAIN EMPLOYEES ON ALL
SPECIAL HNDLG PROC BEFORE THEY WORK W/THIS PROD. FOLLOW ALL PREC INFO GIVEN
ON CONTR LABEL, PROD BULLETINS & MFR SOLV CEMENTING LITERATURE. ALL
HNDLG EQUIP SHOULD BE ELEC GROUNDED.
*
Fire and Explosion Hazard Information
*
Flash Point Method: TCC
Lower Limits: 2.0%
Extinguishing Media: ANSUL "PURPLE K" POTASSIUM BICARBONATE, DRY CHEM, CARBON
DIOXIDE. NATIONAL AER-O-FOAM UNIVERSAL ALCOHOL (SUP DAT)
Fire Fighting Procedures: WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP
N). EVACUATE ENCLSD AREAS, STAY UPWIND. USE WATER SPRAY TO COOL CONTRS, TO
FLUSH SPILLS FROM SOURCE (SUP DAT)
Unusual Fire/Explosion Hazard: FIRE HAZARD BECAUSE OF LOW FLASH POINT AND HIGH
VOLATILITY. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL TO SOURCE OF IGNITION.
*
*
Respiratory Protection: ATM LEVELS SHOULD BE MAINTAINED BELOW ESTABLISHED EXPOS
LIM CONTAINED IN INGRED SECTION. IF AIRBORNE CONCS EXCEED THOSE LIM, USE
NIOSH/MSHA APPRVD ORG VAP CARTRIDGE RESP W/FULL FACE-PIECE REC. EFFECTI
VENESS OF AIR-PURIFYING RESP IS
Ventilation: USE ONLY WITH ADEQUATE VENTILATION. PROVIDE SUFFICIENT VENTILATION
IN VOLUME AND PATTERN TO KEEP CONTAMINANTS
Other Protective Equipment: IMPERVIOUS APRON AND A SOURCE OF RUNNING WATER TO
FLUSH THE EYES AND SKIN IN CASE OF CONTACT.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: SOL IN H*2O: SOLVENT PORTION COMPLETELY SOLUBLE
IN WATER. RESIN PORTION SEPARATES OUT. EXTING MEDIA: RESISTANT FOAM, WATER
SPRAY. FIRE FIGHT PROC: OF IGNIT & TO DISPERSE VAPS. EFTS OF OVEREXP:
DAYS. E LEVATION OF SGPT SUGGESTS DISTURBANCE IN LIVER FUNCTION. NOEL WAS
*
Physical/Chemical Properties
*
Evaporation Rate & Reference: >1.0 (BUTYL ACETATE=1)
Solubility in Water: (SUP DAT)
Appearance and Odor: GRAY, MEDIUM SYRUPY LIQUID WITH ETHEREAL ODOR
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME AND OTHER
SOURCES OF IGNITION.
Materials To Avoid: CAUSTICS, AMMONIA, INORGANIC ACIDS, CHLORINATED COMPOUNDS,
STRONG OXIDIZERS AND ISOCYANATES.
Hazardous Decomposition Products: WHEN FORCED TO BURN, THIS PRODUCT GIVES OUT
CARBON MONOXIDE, CARBON DIOXIDE, HYDROGEN CHLORIDE AND SMOKE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Assigned IND: Y
Company Name: IPS CORP
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE: INHAL: SEVERE OVEREXP MAY RESULT IN
NAUSEA, DIZZINESS, HEADACHE. CAN CAUSE DROWSINESS, IRRIT OF EYES & NASAL
PASSAGES. SKIN: IRRIT. LIQ CONT MAY REMOVE NATURAL SKIN OILS RESULTING IN
SKIN IRRIT. DERMATITIS MAY OCCUR W/PROLONGED CONT. SKIN ABSORPTION:
PROLONGED/WIDESPREAD EXPOS MAY RESULT IN ABSORPTION OF HARMFUL AMOUNTS OF
MATERIAL. EYES: OVEREXP MAY RESULT IN SEVERE EYE INJURY W
/CORNEAL/CONJUNCTIVAL INFLAMMATION ON CONT W/LIQ. VAPORS SLIGHTLY
UNCOMFORTABLE. INGEST: MODERATE TOXICITY. MAY CAUSE NAUSEA, VOMITING,
DIARRHEA. MAY CAUSE MENTAL SLUGGISHNESS. CHRONIC: ANIMAL STUDIES SHOW LIVER
EFFECTS, RESP TRACT IRRIT & DAMAGE.
*
| 1 | gloves_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
------------------------------
% low Wt: 1.
% high Wt: 5.
ACGIH STEL: NOT ESTABLISHED
------------------------------
% low Wt: .5
% high Wt: 5.
ACGIH STEL: NOT ESTABLISHED
------------------------------
% low Wt: 1.
% high Wt: 5.
OSHA PEL: see Table Z-3
ACGIH TLV: 0.1 MG/M3
ACGIH STEL: NOT ESTABLISHED
-----------------------------
ACGIH TLV: 2 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
% low Wt: 1.
% high Wt: 5.
OSHA PEL: C5 MG/M3
ACGIH TLV: 5 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
< Wt: 1.
OSHA PEL: 1 MG/M3
ACGIH TLV: 1 MG/M3
ACGIH STEL: NOT ESTABLISHED
-----------------------------
% low Wt: 1.
% high Wt: 5.
ACGIH STEL: NOT ESTABLISHED
------------------------------
% low Wt: 1.
% high Wt: 5.
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: SHORT TERM EXPOSURE TO WELDING FUMES: DIZZINESS, NAUSEA,
DRYNESS/IRRITATION OF NOSE/THROAT/LUNGS/EYES. LONG TERM EXPOSURE TO WELDING
FUMES: RESPIRATORY PROBLEMS, IRON BUILD-UP IN THE LUNGS, BONE EROSI ON,
REDUCED PULMONARY FUNCTIONS & NERVOUS DISORDERS.
Explanation Of Carcinogenicity: SEE INGREDIENTS.
Signs And Symptions Of Overexposure: SHORT TERM EXPOSURE TO WELDING FUMES:
DIZZINESS, NAUSEA, DRYNESS/IRRITATION OF NOSE/THROAT/LUNGS/EYES. LONG TERM
EXPOSURE TO WELDING FUMES: RESPIRATORY PROBLEMS, IRON BUILD-UP IN THE LUNGS,
BONE EROSI ON, REDUCED PULMONARY FUNCTIONS & NERVOUS DISORDERS.
Medical Cond Aggravated By Exposure: PRE-EXISTING RESPIRATORY/ALLERGETIC
CONDITIONS.
First Aid: IF OVERCOME BY SMOKE/FUMES, REMOVE VICTIM TO FRESH AIR. EMPLOY FIRST
AID TECHNIQUES RECOMMENDED BY THE RED CROSS. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
*
Handling and Disposal
*
Waste Disposal Methods: PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSIBLE CONTAINER/LINER IN AN
ENVIRONMENTALLY ACCEPTABLE MANNER IAW/LOCAL, STATE & FEDERAL REGULATIONS.
Handling And Storage Precautions: MONITOR THE AIR TO ENSURE THE LEVELS ARE
BELOW RECOMMENDED LIMITS. WEAR APPROPRIATE EQUIPMENT TO PREVENT INJURY FROM
RADIATION/SPARKS/ELECTRIC SHOCK.
Other Precautions: TRAIN WELDER NOT TO TOUCH LIVE ELECTRICAL PARTS &
INSULATE THEMSELVES FROM WORK & GROUND. ARC RAYS CAN INJURE EYES &
BURN SKIN. ELECTRIC SHOCK CAN KILL. FUMES & GASES CAN BE DANGEROUS TO
YOUR HEALTH.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NON-FLAMMABLE
*
*
Respiratory Protection: WEAR RESPIRATOR/AIR SUPPLIED RESPIRATOR WHEN WELDING IN
CONFINED SPACE, WHERE LOCAL EXHAUST/VENTILATION DOES NOT KEEP EXPOSURE BELOW
TLV.
Ventilation: LOCAL EXHAUST AT ARC TO KEEP FUMES/GASES BELOW TLV IN WORKERS
BREATHING ZONE & GENERAL AREA.
Other Protective Equipment: ARM PROTECTOR, APRON, HAT, SHOULDER PROTECTION,
DARK SUBSTANTIAL CLOTHING.
Supplemental Safety and Health: PRODUCT IS NON-HAZARDOUS UNTIL USED AS IN
WELDING PURPOSES. THE COMPOSITION & QUANTITY OF FUMES/GASES DEPENDS ON
METAL BEING WELDED, PROCESS, PROCEDURES, ELECTRODES USED, COATINGS, POSITION
OF WELDERS HEAD W/RESPECT TO THE PLUME & AS WELL AS THE PRESENCE OF
CONTAMINANTS IN THE ATMOSPHERE.
*
Physical/Chemical Properties
*
Appearance and Odor: SHIELDED METAL ARC WELDING ELECTRODES
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: SEE SUPPLEMENTAL DATA
Materials To Avoid: SEE SUPPLEMENTAL DATA
Hazardous Decomposition Products: OXIDES OF IRON, MANGANESE, SILICON, CHROMIUM,
NICKEL, MOLYBDENUM, CALCIUM, MAGNESIUM, TITANIUM
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: HOBART BROTHERS CO
Label Required IND: Y
Status Code: A
Origination Code: G
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
ONLY NIOSH/MSHA APPROVED RESPIRATORS TO KEEP BELOW TLV.
Ventilation:PROVIDE MECHANICAL OR LOCAL EXHAUST VENTILATION TO PREVENT
BUILD-UP OF VAPORS & TO KEEP BELOW TLV.
Other Protective Equipment:EYE WASH & SAFETY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS THOROUGHLY AFTER HANDLING, BEFORE EATING &
SMOKING.
Supplemental Safety and Health
CON'T INHALATION: PERMANENT BRAIN/NERVOUS SYSTEM/LIVER/KIDNEY DAMAGE.
CARDIAC/BLOOD ABNORMALITIES. DEATH. SKIN:
DERMATITIS/DEFATTING/ALLERGIC REACTION/BURNS/SENSITIZATION. EYES:
BLURRED VISION/TEARING /REDNESS/BURNS/CORNEAL INJURY. INTENTIONAL
MISUSE BY CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR
FATAL.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ORGANOPHILIC CLAY; QUARTERNARY AMMONIUM COMPOUNDS,
BIS(HYDROGENATED TALLOW ALKYL)DIMETHYL, CHLORIDES, CMPDS
W/BECTORITE
Fraction by Wt: 1-5%
Ingred Name:ALUMINUM (POWDER)
Ingred Name:PROPYLENE GLYCOL METHYL ETHER (1-METHOXY-2-PROPANOL)
PROPYLENE GLYCOL MONO METHYL ETHER
Fraction by Wt: 1-5%
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
Ingred Name:BISPHENOL A DIGLYCIDYL ETHER RESIN, EPOXY RESIN,
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF RESPIRATORY
TRACT. SKIN/EYES: IRRITATION. INGESTION: LARGE AMOUNTS MAY CAUSE
LUNG INFLAMMATION & DAMAGE DUE TO ASPIRATION OF MATERIAL INTO
LUNGS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: MUCOUS MEMBRANE
IRRITATION/FATIGUE/DROWSINESS/DIZZINESS/LIGHTHEADEDNESS/HEADACHE/UN
COORDINATION/NAUSEA/VOMITING/COUGHING/SPEECH DIFFICULTY/MENTAL
APATHY/CNS DEPRESSION/INTOXICATION/CONFUSI ON/ANESTHETIC
EFFECT/NARCOSIS/BREATHINGDIFFICULTY/RESPIRATORY TRACT
SENSITIZATION. SEE SUPPLEMENTAL FOR CON'T.
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY, LUNG,
ASTHMA-LIKE CONDITIONS, CARDIAC ABNORMALITIES, KIDNEY, LIVER &
NERVOUS SYSTEM DISORDERS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY. SKIN: WASH
W/PLENTY OF SOAP & WATER. EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR
CASES.
* Fire Fighting Measures *
Lower Limits:6%
Extinguishing Media:DRY CHEMICAL OR FOAM
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT OR FIRE. VAPORS CAN FORM EXPLOSIVE MIXTURES
IN AIR AT ELEVATED TEMPERATURES. FLAMMABLE LIQUID.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. VENTILATE
AREA W/EXPLOSION PROOF EQUIPMENT. SPILLS MAY BE COLLECTED
W/NON-COMBUSTIBLE ABSORBENT MATERIALS.
*Handling and Storage *
VENTILATION. DON'T TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
AVOID CONTACT W/SKIN, EYES, & BREATHING VAPORS.
Other Precautions:KEEP CONTAINERS TIGHTLY CLOSED & UPRIGHT WHEN NOT IN
USE. EMPTY CONTAINERS MAY CONTAIN HAZARDOUS RESIDUES. GROUND
EQUIPMENT WHEN TRANSFERRING TO PREVENT ACCUMULATION OF STATIC
CHARGE. AVOID SPRAYING O R ABRADING PAINTED SURFACES.
* Physical/Chemical Properties *
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES, ALDEHYDES, REDUCING AGENTS,
ISOCYANATES
Stability Condition to Avoid:ELEVATED TEMPERATURES, HEAT, SPARKS, OPEN
FLAME OR OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CO, CO2
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/ALL APPLICABLE
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS. FLAMMABLE LIQUID.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
BY DGSC-STF.
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
* Physical/Chemical Properties *
HCC:A2
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATORY PROTECTION
EQUIPMENT WHEN AIR CONTAMINANTS EXCEED TLV.
Ventilation:LOCAL EXHAUST, ENCLOSED SYSTEM DESIGN SUFFICIENT IN VOLUME
& PATTERN TO KEEP AIR CONTAMINANT CONCENTRATION BELOW TLV.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PROPANE
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
Ingred Name:METHYLCYCLOHEXANE
Fraction by Wt: 1-5%
Ingred Name:TOLUENE
Fraction by Wt: 1-5%
Ingred Name:HEPTANE
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: HARMFUL, NOSE, THROAT &
LUNG IRRITATION, CENTRAL NERVOUS SYSTEM DEPRESSION, HEADACHE,
DIZZINESS, NAUSEA, VOMITING, UNCONSCIOUSNESS, DROWSINESS, &
ASPHYXIATION. INGESTION: LIVER & KIDNEY DA MAGE. EYES/SKIN:
IRRITATION.
Explanation of Carcinogenicity:NONE
* First Aid Measures *
INGESTION: DILUTE BY DRINKING PLENTY OF WATER. CONTACT POISON
CONTROL CENTER. INHALATION: REMOVE TO FRESH AIR. IF BREATHING
STOPS, GIVE ARTIFIC IAL RESPIRATION, PREFERABLY MOUTH-TO-MOUTH.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, BUT SHOULD BE USED
TO KEEP FIRE-EXPOSED CONTAINER COOL.
Unusual Fire/Explosion Hazard:VAPOR MAY IGNITE EXPLOSIVELY. SPRAY
MIST/VAPOR IS HEAVIER THAN AIR & MAY SETTLE IN LOW PLACES OR TRAVEL
OUTWARD TO IGNITION SOURCE & FLASHBACK.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. SOAK UP
W/ABSORBENT MATERIAL & REMOVE TO CHEMICAL DISPOSAL AREA. PREVENT
ENTRY INTO NATURAL BODIES OF WATER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN WELL-VENTILATED AREA. KEEP
CONTAINER MAY CONTAIN PRODUCT RESIDUES.
Other Precautions:AVOID SKIN & EYE CONTACT. USE W/ADEQUATE VENTILATION.
AVOID BREATHING VAPORS/SPRAY MIST.
* Physical/Chemical Properties *
Spec Gravity:>1
pH: 7
Evaporation Rate & Reference:(BU AC = 1): >1
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR LIQUID & LIQUIFIED GAS W/HYDROCARBON SOLVENT
ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, HIGH TEMPERATURES, DIRECT SUNLIGHT,
SPARKS, RADIATORS, STOVES, & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO & CO2
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. EMPTY CONTAINERS MAY CONTAIN EXPLOSIVE VAPORS.
INCINERATION WILL CAUSE CONTAINER TO BURST VIOLENTLY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PREC:1:EMPLOYEES SHOULD BE APPRAISED OF HAZARDS & PROPER
CONDITIONS & PRECS FOR SAFE USE OR EXPOS. 2:NIOSH/MSHA APPRVD RESPS
SHOULD BE MINIMIZED BY USE OF DUST CONTROL EQUIP OR WATER SPRAY.
4:WEAR PROT CLTHG & VACUUM CLEAN PRIOR TO REMOVING(SEE ING 3)
* Product Identification *
Product ID:CER-FLEX VENEER MORTAR
* Composition/Information on Ingredients *
Ingred Name:ING 4:MAY CAUSE DELAYED LUNG INJURY, (SILICOSIS).
Ingred Name:CRYSTALLINE SILICA
Fraction by Wt: >1%
Ingred Name:SUPP DATA:CLOTHING. 5:WHERE THERE IS POSS OF EXPOS TO DUST
CONTAINING CRYSTALLINE SILICA, FOLLOWING WARNING (SEE ING 4)
Ingred Name:ING 3:SHOULD BE POSTED IN A READILY VISIBLE
LOCATION:WARNING:FREE SILICA WORK AREA. AVOID BREATHING DUST. (SEE
ING 5)
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
DESIGNED FOR ATTACHING CERAMIC FIBER MODULES. THIS PROD CONTAINS
MORE THAN 1% CRYSTALLINE SILICA (FREE SILICA). THE CURRENT OSHA PEL
FREE SILICA PLUS TWO, AVERAGED OVER AN 8-HOUR WORKSHIFT. PRODUCT
DRIES (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:AFTER USAGE. WHEN PROD IS REMOVED
AFTER ITS USEFUL LIFE (TEAR OUT), DUST GENERATION IS LIKELY. THE
USER SHOULD BE WARNED OF CURRENT PEL & PRECS SHOULD BE TAKEN TO
AVOID INHAL OF DUST. CAN CAU SE IRRITATION TO EYE ON CONTACT & TO
SKIN ON PRLNGD CONTACT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
MD. SKIN:WASH OFF THOROUGHLY USING MILD SOAP AND WATER.
INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ART RESP) .
INGEST:CALL MD IMMEDIATELY.
* Fire Fighting Measures *
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE TO THE
SURROUNDING AREA.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:THIS MATERIAL IS NON-COMBUSTIBLE.
* Accidental Release Measures *
Spill Release Procedures:SPILLS SHOULD BE CLEANED UP TO AVOID SLIPPING.
CLEANUP PERSONNEL SHOULD AVOID SPLASHING & SPLATTERING OF MATLS.
APPROPRIATE CLOTHING FOR EYE AND SKIN PROTECTION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:ADHERENCE TO PROPER METHODS OF DUST
SUPRESSION AND CONTROL IS IMPERATIVE.
Other Precautions:BECAUSE OF POSS PRESENCE OF CRYSTALLINE SILICA IN
USED REFRACTORY LININGS, PARTICULAR CARE SHOULD BE EXCERCISED
DURING TEAR OUT TO MINIMIZE GENERATION OF DUST. FOLLOWING AREA
RECOMMMENDED PRECS TO BE TAKEN DURING REMOVAL:(SEE SUPP DATA)
* Physical/Chemical Properties *
HCC:T6
Appearance and Odor:ODORLESS GRAY SUSPENSION, SUPPLIED IN A WET
CONSISTENCY OF A STANDARD MORTAR.
* Stability and Reactivity Data *
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:MATERIAL IS AIR SETTING. KEEP IN SEALED
CONTAINERS UNTIL READY TO USE AND RESEAL PARTIALLY USED CONTAINERS.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
HAZARDOUS WASTE WHEN DISCARDED AS DEFINED IN THE UNITED STATES EPA
FEDERAL, STATE AND LOCA L DISPOSAL REQUIREMENTS.
| 1 | gloves_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: MAY CAUSE MINOR TRANSIENT IRRITATION. NO CORNEAL
INJURY LIKELY. SKIN: MAY CAUSE MINOR IRRITATION. MAY CAUSE SKIN
SENSITIZATION. NOT LIKELY TO BE ABSORBED IN TOXIC AMOUNTS. INGESTION: LOW IN
TOXI CITY. INHALATION: RESPIRATORY TRACT IRRITATION NOT LIKELY.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: PREEXISTING SKIN AND EYE DISORDERS.
GET MED ATTN. SKIN: WIPE OFF CONTAM & PROMPTLY WASH W/SOAP & WATER.
INGEST: IF CONSCIOUS, GIVE WATER & INDUCE VOMIT BY INSERTING FIN GER DOWN
THROAT. OBTAIN MED TREATMENT. INHAL: IMMED MOVE TO FRESH AIR, KEEP VICTIM
QUIET, ADMIN CPR &/OR OXYGEN AS REQD. OBTAIN MED ASSISTANCE. NOTE TO MD:
PREEXISTING SKIN ALLERGIES MAY (SUPDAT)
*
Handling and Disposal
*
Spill Release Procedures: ABSORB WITH INERT MATERIAL (CLAY, SAND, ETC.) AND
PLACE IN APPROPRIATE CONTAINERS WITH NON-SPARKING TOOLS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF MATERIAL ACCORDING TO ALL FEDERAL, STATE AND
LOCAL LAWS.
Handling And Storage Precautions: STORE IN COOL, DRY PLACE. KEEP AWAY FROM OPEN
FLAMES & HIGH TEMP. PRACTICE GOOD CAUTION & PERSONAL CLEANLINESS TO
AVOID SKIN & EYE CNTCT.
Other Precautions: CNTNR HAZ WHEN EMPTY. SINCE EMPTY CNTNRS RETAIN RESIDUES
(VAP, LIQ/SOLIDS) ALL LABELED HAZ PREC MUST BE OBSERVED. DO NOT REUSE EMPTY
CNTNR FOR FOOD, CLTHG/PRODS FOR HUMAN OR ANIMAL CONSUMPTION/SKIN CN TCT W/OUT
PROFESSIONAL CLEANING.
*
Fire and Explosion Hazard Information
*
Flash Point Method: TOC
Extinguishing Media: FOAM, CARBON DIOXIDE, DRY CHEMICAL OR WATER SPRAY.
Fire Fighting Procedures: USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP(FP
N). WATER SHOULD BE USED TO KEEP FIRE-EXPOS CNTNRS COOL. IF LEAK/SPILL HAS
NOT IGNITED, USE WATER SPRAY (SUPDAT)
Unusual Fire/Explosion Hazard: NO UNUSUAL HAZARDS.
*
*
Respiratory Protection: NONE NORMALLY NEEDED. USE A NIOSH/MSHA APPROVED
RESPIRATOR WITH VAPOR/GAS FILTER FOR PERSONAL COMFORT.
Ventilation: GOOD ROOM VENTILATION USUALLY ADEQUATE FOR MOST OPERATIONS.
Other Protective Equipment: CLEAN, BODY-COVERING CLOTHING TO MINIMIZE CONTACT.
Work Hygienic Practices: WASH THORO AFTER HNDLG. REMOVE & WASH CONTAMINATED
CLTHG BEFORE REUSE. CONTAMINATED LEATHER SHOES SHOULD BE DISCARDED.
Supplemental Safety and Health: USERS OF L VERSION SHOULD CONSULT LR VERSION
FOR ADDNL INFO (FP N). FIRE FIGHT PROC: TO DISPERSE VAPS & PROTECT PERS
ATTEMPTING TO STOP LEAK. FIRST AID PROC: INCR CHANCE OF DEVELOPING INCR
ALLERGY SYM P FROM EXPOS. ALLERGY (SKIN SENSIT) MAYBE EVID BY RASHES, ESP
HIVES. PREEXISTING SKIN & EYE DISORDERS MAY BE
*
Physical/Chemical Properties
*
Vapor Density: 8.5
Spec Gravity: 1.2 (H*2O=1)
Solubility in Water: NEGLIGIBLE
Appearance and Odor: YELLOW-BROWN CLEAR VISCOUS LIQUID; PENETRATING ODOR.
Percent Volatiles by Volume: NIL
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: EXCESS HEATING OVER LONG PERIODS OF TIME DEGRADES
RESIN.
Materials To Avoid: STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS &
CAUSTICS.
Hazardous Decomposition Products: NONE UNDER NORMAL USE. CARBON MONOXIDE,
ALDEHYDES & ACIDS MAY BE FORMED DURING COMBUSTION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Assigned IND: Y
Company Name: THE EPOXYLITE CORPORATION
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: EYES: MAY CAUSE MINOR TRANSIENT
IRRITATION. NO CORNEAL INJURY LIKELY. SKIN: MAY CAUSE MINOR IRRITATION. MAY
CAUSE SKIN SENSITIZATION. NOT LIKELY TO BE ABSORBED IN TOXIC AMOUNTS. IN
GESTION: LOW IN TOXICITY. INHALATION: RESPIRATORY TRACT IRRITATION NOT
LIKELY. CHRONIC: NONE LISTED BY MANUFACTURER.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER AND EYE
BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE AND BEFORE EATING,
DRINKING, SMOKING OR USING SANITARY FACILITIES .
Supplemental Safety and Health
DECOMP PRODS MAY INCLUDE HCL. HAZ DECOMP PRODS: AND/OR PHOSPHINE.
OTHER PREC: HCL.
* Product Identification *
Product ID:BIS(DIMETHYLAMINO) (SEE SUPP DATA)
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF SWALLOWED, INHALED,
OR ABSORBED THRU SKIN. MATL IS EXTREMELY DEST TO TISS OF MUC MEMB &
UPPER RESP TRACT, EYES & SKIN. INHAL MAY BE FATAL AS A RESULT OF
SPASM, INFLAM & EDEMA OF THE LARYNX & BRONCHI, CHEM PNEUM & PULM
EDEMA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:BURNING SENSATION, COUGHING, WHEEZING,
LARYNGITIS, SHORTNESS OF BREATH, HEADACHE, NAUSEA & VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYES & SKIN: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER
SHOES. WASH BEFORE REUSE. DISCARD CONTAMINATED SHOES. ASSURE ADEQ
FLUSHING OF EYES BY SEPARATING LIDS WITH FINGERS. INHAL: REMOVE TO
FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. CALL MD. INGEST: CALL MD
IMMEDIATELY .
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:CO*2, DRY CHEMICAL POWDER, ALCOHOL OR POLYMER FOAM.
DO NOT USE WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:EMITS TOX FUMES UNDER FIRE CNDTNS. WATER
HYDROLYZES MATL LIBERATING ACIDIC GAS WHICH IN CONT W/METAL SURF
CAN GEN FLAM AND/OR EXPLO HYDROGEN GAS. (SUPP DATA)
* Accidental Release Measures *
Spill Release Procedures:EVAC AREA. WEAR NIOSH/MSHA APPROVED SCBA,
AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL. VENTILATE AREA AND
WASH SPILL SITE AFTER MATE RIAL PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT BREATHE VAPOR. KEEP TIGHTLY
CLOSED. STORE IN A COOL DRY PLACE.
Other Precautions:DO NOT GET IN EYES, ON SKIN OR CLTHG. AVOID
PRLNGD/RPTD EXPOS. CORR. MOISTURE-SENSITIVE. NO SMOKING IN AREA OF
USE. DO NOT USE IN GEN VICINITY OF ARC WELDING/OPEN FLAMES/HOT
SURF. HEAT AND/OR UV RADIA TION MAY CAUSE FORMATION OF (SUPP DATA)
* Physical/Chemical Properties *
HCC:C2
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:MAY DECOMPOSE ON EXPOSURE TO MOIST AIR OR
WATER.
Hazardous Decomposition Products:TOX FUMES OF: CO, CO*2, NO*X, HYDROGEN
CHLORIDE GAS. THER DECOMP MAY PRODUCE TOX FUMES OF PHOSPHORUS
OXIDES (SUPP DATA)
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. DISPOSE OF IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL LAWS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH OIL MIST RESPIRATOR IF OVER TLV.
Ventilation:USE LOCAL EXHAUST,IF NEEDED TO REDUCE EXPOSURE BELOW TLV.
Other Protective Equipment:NONE
Work Hygienic Practices:USE NORMAL PERSONAL HYGIENE PROCEDURES
Supplemental Safety and Health
* Product Identification *
Preparer's Name:WILLIAM CARTER
CAGE:0CHX4
* Composition/Information on Ingredients *
Ingred Name:SOLUBLE OIL.(MFR LISTS HAZARDOUS & TOXIC INGREDIENTS AS
"NONE")
OSHA PEL:5 MG/CUM(OIL MIST)
ACGIH TLV:5 MG/CUM(OIL MIST)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:PROLONGED CONTACT MAY CAUSE DERMATITIS.
* First Aid Measures *
First Aid:EYES:FLUSH WITH LARGE QUANTITIES OF WATER. SKIN:WASH WITH
SOAP & WATER. INHALED:REMOVE TO FRESH AIR AND CALL A PHYSICIAN.
INGESTED:IMMEDIATELY CALL A PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER FOG.
Fire Fighting Procedures:TREAT AS AN OIL FIRE. USE WATER ONLY AS A FOG.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:RECOVER AS LIQUID IF POSSIBLE;OTHERWISE,
ABSORB ON INERT MATERIAL. PLACE IN CLOSED CONTAINER PENDING
DISPOSAL.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:STORE AS HIGH FLASH POINT OIL.
* Physical/Chemical Properties *
HCC:N1
Evaporation Rate & Reference:NIL
Appearance and Odor:AMBER LIGHT OIL, BLAND OIL ODOR
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:NORMAL HYDROCARBON COMBUSTION
PRODUCTS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATION.
HMIS SUGGESTS INCINERATION.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE, AIE SUPPLIED APPARATUS FOR CONFINED
SPACES.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:NONE
Work Hygienic Practices:WASH HANDS AFTER USE.
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:DRY CLEANING SOLVENT
* Composition/Information on Ingredients *
Ingred Name:BLEND OF MINERAL SPIRITS
Other REC Limits: RECOMMENDED
Ingred Name:METHYLENE CHLORIDE(DICHLOROMETHANE) (SARA III)
Other REC Limits: RECOMMENDED
Ingred Name:PERCHLOROETHYLENE (TETRACHLOROETHYLENE) (SARA III)
Fraction by Wt: 5%
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALING: ANESTHETIC, IRRITATES
RESPIRATORY TRACT, MAY CAUSE SERIOUS NERVOUS DEPRESSION. SKIN OR
EYE CONTACT: PRIMARY IRRITATION.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure: SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure: SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:IN CASE OF CONTACT WITH SKIN, FLUSH WITH PLENTY OF WATER. FOR
EXPOSED TO HIGH CONCENTRATIONS OF VAPORS, REMOVE TO FRESH AREA. IF
SWA LLOWED, CALL A PHYSICIAN IMMEDIATELY. DO NOT DRINK ALCOHOL
SHORTLY BEFORE, DURING OR AFTER USE.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CARBON DIOXIDE OR
FOAM).
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE ON FIRE BUT CAN
COOL FIRE FIGHTERS AND COOL CLOSED CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:COMBUSTIBLE: KEEP CONTAINER CLOSED,
ISOLATE FROM HEAT, OXIDIZERS AND OPEN FLAMES.
* Accidental Release Measures *
Spill Release Procedures:ISOLATE FROM OXIDIZERS, HEAT AND OPEN FLAMES.
MOP UP AND DISPOSE OF.
Neutralizing Agent: SPECIFIED BY MANUFACTURER.
*Handling and Storage *
LARGE AMOUNTS IN STRUCTURES MADE FOR OSHA II LIQUIDS.
Other Precautions:GROUND CONTAINERS WHEN POURING. DO NOT FLAME CUT
EMPTY CONTAINERS.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:4.1
pH:7
Solubility in Water:NEGLIGIBLE
Appearance and Odor: SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE FROM STRONG OXIDANTS SUCH AS PERMANGANATE.
Stability Condition to Avoid:ISOLATE FROM HEAT AND OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE AND HYDROGEN CHLORIDE
WITH TRACES OF PHOSGENE.
* Disposal Considerations *
Waste Disposal Methods:RECYCLE AND DISPOSE OF OBSERVING LOCAL, STATE
AND FEDERAL HEALTH, SAFETY AND POLLUTION LAWS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:USE WITH ADEQUATE VANTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:MIGHTY MATE
* Composition/Information on Ingredients *
Ingred Name:SOLVENT NAPHTHA;(HEAVY AROMATIC NAPHTHA)
Ingred Name:POTASSIUM VEGETABLE OIL SOAP;(POTASSIUM VEGETABLE PINE OIL
SOAP)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE IRRITANT. INHAL:EXCESSIVE
INHALATION CAUSES HEADACHE, DIZZINESS, NAUSEA. INGEST:HARMFUL. IF
PRODUCT IS USED FULL STRENGTH AND COMES INTO CONTACT WITH HOT
SURFACES, FUMES MAY CAUSE TEMPORARY DIZZIN ESS, HEADACHES.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:
Medical Cond Aggravated by Exposure:
* First Aid Measures *
IRRITATION PERSISTS. SKIN:WASH WITH MILD SOAP & WATER. APPLY SKIN
CREAM. INHAL:MOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . INGEST:DRINK PLENTY OF WATER. GET MD IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:WATER SPRAY, FOAM, CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:MOP UP EXCESS, RINSE AREA WITH WATER. REMOVE
SATURATED CLOTHING AND WASH AFFECTED SKIN WITH MILD SOAP & WATER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:UNDER NORMAL USE CONDITIONS MATERIAL
IS NOT CONSIDERED HAZARDOUS.
Other Precautions:
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:DILUTABLE
Appearance and Odor:GOLDEN YELLOW LIQUID, AROMATIC ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG CAUSTICS OR STRONG ACIDS.
Stability Condition to Avoid:
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE MAY
BE FORMED AT EXTREMELY HIGH TEMPERATURES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL SHALL BE IN ACCORDANCE WITH LOCAL,
STATE ANED FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATOR RECOMMENDED FOR USE IN ORGANIC VAPOR
ENVIRONMENT (AIR PURIFYING/AIR SUPPLIED).OBEY OSHA REGS FOR
RESPIRATOR. VENT TO KEEP EXPOSURE LEVELS BELOW OSHA LIMITS. VAPOR
Ventilation:EXHAUST VENT TO KEEP AIRBORNE CONCENTRATION OF SOLVENT, HDI
& POLYISOCYANATES BELOW TLV. REMOVE IGNITION SOURCES.
Other Protective Equipment:THE USE OF LONG SLEEVE AND LONG LEG CLOTHING
IS RECOMMENDED. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
Preparer's Name:NORM GAUL
* Composition/Information on Ingredients *
Ingred Name:ALIPHATIC ISOCYANATE (VAPOR PRESSURE 0 MM HG)
Other REC Limits:NONE RECOMMENDED
Ingred Name:HEXAMETHYLENE DIISOCYANATE (CERCLA) (HDI) (FREE MONOMER
<0.5% RESIN SOLIDS (TIME OF MFR); AFTER 3-6 MO,MAY RISE 1.6 MAX)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:RESP TRACT IRRIT
(HEADACHE,DIZZY,STAGGER,CONFUSION,UNCONSCIOUS,COMA).
SKIN:ISOCYANATES REACT W/SKIN PROTEIN & MOISTURE.IRRIT
(SWELL,RED,RASH).ABSORPTN:IRRIT (DRY,DEFAT,SKIN CRACK). EYES:IRRIT
(T EAR,RED,SWELL W/STING). INGEST:IRRIT, CORROSIVE IN GI
TRACT.VOMITING MAY CAUSE ASPIRATION,RESULTING IN CHEM PNEUMONITIS.
Effects of Overexposure:ACUTE: VAPORS ARE IRRITATING TO EYES, NOSE, &
THROAT. INHALATION MAY CAUSE HEADACHES, DIFFICULT BREATHING &
UNCONSCIOUSNESS. CHRONIC: AS RESULT OF PREVIOUS REPEATED
OVEREXPOSURE OR SINGLE LARGE DOSE,CERTAIN INDIVIDUALS WILL
DEVELOP ISOCYANATE SENSITIZATION (REACT TO LATER EXPOSURE OF
ISOCYANATE LEVELS BELOW TLV).
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS. ISOCYANATE
SENSITIZATION.
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR.RESTORE BREATHING.ASTHMATIC TYPE
SYMPTOMS MAY DEVELOP (IMMEDIATE/DELAYED BY SEVERAL HRS).GET MEDICAL
AID. SKIN:REMOVE CONTAMINATED CLOTHING.WASH AFFECTED AREAS W/SOAP &
WATER.W ASH CONTAMINATED CLOTHING BEFORE REUSE.EYES:FLUSH
INGEST:DON'T INDUCE VOMITING.DON'T GIVE ANYTHING TO UNCONSCIOUS
PERSON.GET MED AID.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG,
WATER SPRAY
Fire Fighting Procedures:USE FULL PROTECT CLOTH/FIREFIGHT EQUIP W/SCBA.
WATER MAY BE USED TO COOL CLSD CNTNRS (PREVENT PRESS
BLDUP/AUTOIGNIT/EXPLOS). HDI/IRRIT VAPOR GENERATED BY FIRE.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. KEEP FROM HEAT/IGNIT
SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT. APPLIC TO HOT SURFACE REQ
SPECIAL PRECAUTION. OVEREXPOSURE TO DECOMP PROD-HLTH HZD.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN & REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN BLDG IN COMPLY W/OSHA
TEMP/IGNIT SOURCE.PREVENT PROLONGED VAPOR BREATHING
Other Precautions:KEEP CONTAINERS TIGHT & UPRIGHT (PREVENT LEAK).
PROLONGED OVEREXPOSURE MAY CAUSE ALLERGIC REACTION. AVOID CONTACT
WITH SKIN & EYES. DO NOT INGEST. DO NOT HANDLE TILL MFR'S
PRECAUTIONS READ OR UNDERSTO OD. SMOKE IN SMOKING AREAS ONLY.
* Physical/Chemical Properties *
Vapor Density:> AIR
Viscosity:*
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID WITH SOLVENT ODOR
* Stability and Reactivity Data *
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:CONTACT WITH MOISTURE, MATERIAL WHICH
REACT WITH ISOCYANATES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN, TRACES OF HCN AND
HDI.
* Disposal Considerations *
Waste Disposal Methods:WASTE MUST BE DISPOSED OF IN ACCORDANCE
W/FEDERAL, STATE, & LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY
CONTAINERS MUST BE HANDLED W/CARE, DUE TO PRODUCT RESIDUE &
FLAMMABLE VAPOR. DO NOT INCINERAT E CLOSED CONTAINERS. EPA HZD
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
SHOULD BE USED. VENTILATION RATES HSOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. GOOD INDUSTRIAL
HYGIENE PRACTICES SHOULD BE FOLLOWED.
Supplemental Safety and Health
NONE
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits: RECOMMENDED
Ingred Name:DEXTRINE
Other REC Limits: RECOMMENDED
Ingred Name:SODIUM PHOSPHATE, MONOBASIC
Other REC Limits: RECOMMENDED
Ingred Name:POLY(1-VINYL-2-PYRROLIDI)
Fraction by Wt: 1-5%
Other REC Limits: RECOMMENDED
Ingred Name:SODIUM PHOSPHATE, TRIBASIC (SARA III)
Fraction by Wt: 1-5%
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALE: EXPECTED TO BE A LOW HAZARD
FOR RECOMMENDED HANDLING. EYES: NO SPECIFIC HAZARD KNOWN. MAY CAUSE
TRANSIENT IRRITATION. SKIN: LOW HAZARD FOR RECOMMENDED HANDLING.
INGEST: EXPECTED TO BE A LOW IN GESTION HAZARD.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:EYE IRRITATION.
Medical Cond Aggravated by Exposure: SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALE: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYE: ANY MATERIAL THAT CONTACTS EYE
SHOULD BE WASHED OUT IMMEDIATELY W/WATER. GET MEDICAL ATTENTION IF
SYMPTOMS OC CUR. SKIN: WASH W/SOAP & WATER. GET MEDICAL ATTENTION
IF SYMPTOMS OCCUR. INGEST: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL
ATTENTION.
* Fire Fighting Measures *
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures: (NONCOMBUSTIBLE).
Unusual Fire/Explosion Hazard: (NONCOMBUSTIBLE).
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
OTHERWISE ABSORB SPILL W/VEMICULITE OR TOTHER INERT MATERIAL. THEN
PLACE IN CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO
REMOVE RESIDUAL CONTAM INATION.
Neutralizing Agent: SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. KEEP
CONTAINER CLOSED.
Other Precautions:
* Physical/Chemical Properties *
HCC:N1
Vapor Density:0.6
pH:4.4
Solubility in Water:COMPLETE.
Appearance and Odor:LIQUID, DARK BROWN COLOR, WAXY ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WITH COMMON MATERIALS & CONTAMINANTS WITH WHICH THE MATL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid: SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, LOCAL LAWS. FLUSH TO SEWER WITH LARGE AMOUNTS
OF WATER.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA. WHEN SANDING/ABRADING, USE A
DUST/MIST RESPIRATOR APPROVED BY NIOSH/MSHA.
Ventilation:LOCAL/GENERAL EXHAUST VENTILATION.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
CAGE:WEST1
CAGE:WEST1
* Composition/Information on Ingredients *
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
Fraction by Wt: 5%
Ingred Name:ISOBUTYL ACETATE
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:CARBONIC ACID, CALCIUM SALT (1:1), CALCIUM CARBONATE,
Fraction by Wt: 3%
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
Fraction by Wt: 5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION TO EYES, SKIN & RESPIRATORY
SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME OVEREXPOSURE
MAY RESULT IN UNCONSCIOUSNESS & POSSIBLY DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA, LOSS
OF COORDINATION, REDNESS, ITCHING, BURNING SENSATION.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/WATER
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:1
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR SCBA W/FULL PROTECTIVE CLOTHING. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERRABLE. USE WATER TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT & OTHER IGNITION SOURCES. CLOSED CONTAINERS MAY EXPLODE
WHEN EXPOSED TO EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE TO IGNITION SOURCES. VENTILATE & REMOVE
W/INERT ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:FLAMMABLE. KEEP AWAY FROM HEAT & OTHER
IGNITION SOURCES. USE APPROVED GROUNDING & BONDING PROCEDURES. KEEP
CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE &
APPROPRIATE LABELING. DON'T TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING THE CONTENTS C AN BE HARMFUL/FATAL.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN
FLAME, HOT SURFACES.
Hazardous Decomposition Products:BY FIRE: CO2, CO.
* Disposal Considerations *
Waste Disposal Methods:WASTE MUST BE TESTED FOR IGNITABILITY.
INCINERATE CLOSED CONTAINER. DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED FOR BRUSH & ROLL APPLICATION. FOR
SPRAY APPLICATION, WEAR A PROPERLY FITTED NIOSH/MSHA APPROVED
ARE EXHAUSTED.
Ventilation:PROVIDE SUFFICIENT VENT IN VOLUME & PATTERN TO KEEP AIR
CONC BELOW APPLIC OSHA PEL/ACGIH TLV OCCUP EXPOS LIMITS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . COVERALLS & HOOD ARE REC DURING SPRAY
(SUPDAT)
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING THE RESTROOM.
Supplemental Safety and Health
OTHER PROT EQUIP:APPLICATION. PROTECTIVE CREAMS MAY BE USED FOR EASE OF
CLEAN-UP, NOT FOR PROTECTION.
* Product Identification *
Preparer's Name:J. BURNWORTH
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:OVEREXPOSURE MAY CAUSE HEADACHE,
NAUSEA, SKIN & EYE IRRITATION. INHALATION: INHALATION OF HIGH
CONCENTRATIONS OF VAPORS MAY CAUSE HEADACHE, NAUSEA & IRRITATION OF
NOSE, THROAT & LUNGS. EYE:CONTA CT MAY CAUSE IRRITATION OR BURNING.
SKIN:REPEATED LIQUID CONTACT MAY CAUSE IRRITATION & DERMATITIS.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INGESTION:SWALLOWING CAN CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING & DIARRHEA. VOMITING
CAN RESULT IN ASPIRATION OF MATERIAL INTO LUNGS WHICH CAN CAUSE
CHEMICAL PNEUMONITIS. CHRONIC :UNPROTECTED OVEREXPOSURE TO MISTS
FROMSPRAY APPLICATION MAY CAUSE LUNG DISEASE (SILICOSIS).
Medical Cond Aggravated by Exposure:NONE KNOWN AT THIS TIME.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED, APPLY
ARTIFICIAL RESPIRATION. CONSULT MD. EYE:WASH W/CLEAN WATER FOR AT
WATER. REMO VE CONTAMINATED CLOTHING. CONSULT MD. INGEST:DRINK 1-2
GLASSES OF WATER TO DILUTE. CONSULT MD OR POISON CONTROL CENTER
IMMEDIATELY.
* Fire Fighting Measures *
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD UP & EXPLOSION WHEN EXPOSED TO
EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:VETNILATE AREA. PREVENT SKIN & EYE CONTACT &
BREATHING OF VAPOR. CONTAIN & REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Other Precautions:DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN.
* Physical/Chemical Properties *
Vapor Density:LTR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:DILUTABLE
Appearance and Odor:COLORED LIQUID W/AMMONIACAL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN AT THIS TIME.
Hazardous Decomposition Products:NONE KNOWN AT THIS TIME.
* Disposal Considerations *
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. ABSORB LARGE SPILLS W/SAND, CLAY OR DIATOMACEOUS
EARTH. DISPOSE I/A/W LOCAL, STATE & FEDERAL DISPOSAL REQUIREMENTS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SELF CONTAINED BREATHING APPARATUS OR SUPPLIED
AIR MASK
Ventilation:LOCAL EXHAUST
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:DO NOT INHALE VAPORS. WASH HANDS BEFORE EATING
AND DRINKING.
Supplemental Safety and Health
* Product Identification *
Product ID:TRICHLOROTRIFLUOROETHANE
Preparer's Name:TOM DOYLE
* Composition/Information on Ingredients *
III)
Other REC Limits:NONE SPECIFIED
Ozone Depleting Chemical:1
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and
Chronic:ACUTE-EYE:IRRITATION.,VAPORS:CONJUNCTIVITIS.,LIQUID:FROSTBI
TE,SEVERE IRRITATION. SKIN:IRRITATION. INHALATION:CAN CAUSE
NARCOSIS,UNCONSCIOUSNESS,RESPIRATORY DEPRESSION,
TACHYCARDIA,HYPOTENSION & DEATH DUE TO
ASPHYXIATION.INGESTION:INGESTIONOF TOXIC DOSE IS UNLIKELY.
CARCINOGEN TO HUMAN (IARC).
Effects of Overexposure:INHALATION OF HIGH CONCENTRATION OF
VAPORS:TACHYCARDIA, HYPOTENSION,DEPRESSED VENTICULAR FUNCTION,
SENSITIZATION OF HEART TO EPINEPHRINE. LIQUID CONTACT-
SKIN:FROSTBITE; EYES:SEVERE IRRITATION AND PAI N.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
EYELIDS OPEN. SKIN:IF FROSTBITTEN, WASH WITH WARM WATER SLOWLY.
INHALATION:REMOVE TO FRESH AIR, GIVE CPR/OXYGEN IF NECESSARY. KEEP
VICTIM QUI ET. DON'T GIVE EPINEPHRINE OR SIMILAR DRUGS.
INGESTION:DO NOT INDUCE VOMITING, GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS IF
FIGHTING NEAR THIS PRODUCT DUE TO TOXIC THERMAL DECOMPOSITION
PRODUCTS.KEEP CONTAINER COOL.
Unusual Fire/Explosion Hazard:MAY DECOMPOSE IN CONTACT WITH
FLAMES,HEATING ELEMENTS OR IN GAS ENGINE (EXTREME HEAT) RELEASING
IRRITATING, TOXIC AND CORROSIVE GASES.
* Accidental Release Measures *
Spill Release Procedures:KEEP UPWIND. EVACUATE ENCLOSED SPACE. DISPERSE
GAS WITH FLOOR LEVEL FORCED AIR VENTILATION OR WATER SPRAY. DO NOT
SMOKE. REMOVE FLAMES, HEATING ELEMENTS, GAS ENGINE, ETC. ABSROB
LARGE SPILLS WITH INER T ABSORBENTS,COLLECT IN COVERED DRUMS FOR
DISPOSAL
Neutralizing Agent:NONE
*Handling and Storage *
CONTAINERS IN A COOL, WELL VENTILATED AREA, AWAY FROM HEAT,SPARKS &
FLAMES.
Other Precautions:DO NOT DROP,REUSE OR REFILL CONTAINER.DO NOT STORE IN
EXPOSED SKIN FROM LIQUID CONTACT.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:6.6
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS LIQUID WITH FAINT ETHEREAL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALINE EARTH METALS, POWDERED AL, ZN, BE AND MG.
Stability Condition to Avoid:HIGH TEMPERATURES AND FLAMES
Hazardous Decomposition Products:HYDROGEN FLUORIDE AND CHLORIDE,
CHLORINE, PHOSGENE (POSSIBLY)
* Disposal Considerations *
Waste Disposal Methods:BEST TO RECYCLE OR RECLAIM, IF POSSIBLE.
DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
AUTHORITIES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE GOOD VENT-FOR DUST/MISTS,USE NIOSH/MSHA
CERTIFIED MASK. FOR AIR BRUSH: NIOSH/MSHA CERTIFIED RESP. DO NOT
INHALE SPRAY FROM AIR BRUSH. FOR SANDING DRIED PAINT: USE
NIOSH/MSHA CERTIFIED RESP. DO NOT INHALE FROM SANDING OPERATION.
Ventilation:USE VENT AS REQ TO CONTROL VAP CONC. USE WINDOW EXHST FAN
TO REMOVE VAPS & ASSURE ADEQ CROSS VENTILATION.
Other Protective Equipment:EYEWASH FOUNTAINS & SAFETY SHOWERS SHOULD BE
AVAILABLE FOR USE IN AN EMERGENCY.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
DISPOSAL.
* Product Identification *
CAGE:BINNE
CAGE:BINNE
* Composition/Information on Ingredients *
Ingred Name:ULTRAMARINE BLUE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: INERT, NUISANCE PARTICULATE DUST.
SKIN: NON-TOXIC. INHAL: INERT, NUISANCE PARTICULATE DUST. INGEST:
PRODUCT MAY BE IRRITATING TO GI TRACT IF INGEST. PRODS HAVE BEEN
CERTIFIED AS NON-TOXIC BY ART & CRAFT MATLS INSTITUTE & CONFORM TO
ADVERSE HLTH HAZ.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NO SPECIFIC HAZARD IS KNOWN.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN, EYE AND
RESPIRATORY DISORDERS, IMPAIRED FUNCTIONS FROM PRE-EXISTING
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
MEDICAL ATTN IF ANY SYMPTOMS PERSIST. SKIN:WIPE EXCESS FROM SKIN
AND FLUSH WITH WATER USING SOAP IF AVAILABLE. SEEK MEDICAL ATTN IF
IRRITATIONOCCURS. INHAL:REMOVE VICTIM TO FRESH AIR AND TREAT
SYMPTOMATICALLY. INGEST:CALL MD, HOSPITAL OR POISON CONTROL CENTER
IF PRODUCT IS INGESTED.
* Fire Fighting Measures *
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CO2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PRODUCT AS SUPPLIED WILL SPLATTER AND
* Accidental Release Measures *
Spill Release Procedures:SOAK UP RESIDUE W/AN ABSORB SUCH AS CLAY,
SAND/OTHER SUITABLE MATL; PLACE IN NON-LEAK CNTNRS FOR PROPER DISP.
FLUSH AREA W/WATER TO REMOVE TRACE RESIDUE;DISPOSE OF FLUSH SOLN AS
ABOVE.SM SPILLS-TAKE U P W/AN ABSORB MATL & PLACE IN NON-LEAK (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT INHALE SPRAY FROM
AIRBRUSH/DUSTS FROM SANDING OPERATION.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:>1
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:<1 (ETHER = 1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:CO2, CO AND UNIDENTIFIED (UNKNOWN)
ORGANIC COMPOUNDS MAY BE FORMED DURING COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:REFER TO LATEST EPA OR STATE REGULATIONS
REGARDING PROPER DISPOSAL. DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY NEEDED. USE NIOSH RESPIRATOR OR
SUPPLIED AIR RESPIRATOR IF EXPOSED OVER TLV.
Ventilation:NORMAL ROOM VENTILATION IS USUALLY SUFFICIENT. USE
ADDITIONAL LOCAL EXHAUST AS NEEDED TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:IF USE INVOLVS SPLASHING,ETC. USE
APRONS,BOOTS,ETC. TO PREVENT PROLONGED OR REPEATED CONTACT.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID ANY
UNNECESSARY EXPOSURE.
Supplemental Safety and Health
WITHIN DOD.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ORGANOSILICATE ESTER (PRODUCT OF REACTING SILICON TETRA
CHLORIDE WITH ANHYDROUS ALCOHOL)
Ingred Name:2,6-DI-TERT-BUTYL-P-CRESOL
Fraction by Wt: 0.5%
Ingred Name:MINERAL OIL (EXPOSURE REGULATED AS 'OIL MIST')
Fraction by Wt: 2%
OSHA PEL:5 MG/M3
Ingred Name:2-ETHYL-1-BUTANOL (PRESENT AS A PRODUCT OF HYDROLYSIS. SEE
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS PRACTICALLY NON-TOXIC.
DERMAL CONTACT IS SLIGHTLY IRRITATING. 6 HR INHALATION STUDIES HAVE
SHOWN NO EFFECTS DUE TO THE LOW VOLITILITY OF THE PRODUCT AND THUS
LOW EXPOSURE LEVELS. SEE SUPP D ATA.
Effects of Overexposure:OTHER THAN SLIGHT IRRITATION, NONE WERE
REPORTED.
Medical Cond Aggravated by Exposure:NONE REPORTED.
* First Aid Measures *
First Aid:MFR MADE NO COMMENT ON FIRST AID PROCEDURES. FOLLOWING FROM
CLOTHING. LAUNDER BEFORE RE-USE. WASH PRODUCT FROM SKIN WITH SOAP
AND WATER FLU SH. INHALED:REMOVE TO FRESH AIR. INGESTED:GET
IMMEDIATE MEDICAL ATTENTION. IF IRRITATION FROM ANY CONTACT IS
SEVERE OR PERSISTS,GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:WATER SPRAY,FOAM,DRY CHEMICAL,CARBON DIOXIDE,OR
OTHER MEDIA FOR CLASS B FIRES.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
SELF-CONTAINED BREATHING APPARATUS. DECONTAMINATE EQUIPMENT AFTER
USE.
Unusual Fire/Explosion Hazard:MAY EMIT HAZARDOUS FUME IN FIRE
CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN AND RECOVER LIQUID IF POSSIBLE. ABSORB
ON CLAY,SAWDUST,ETC. IF NOT.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:STORE TIGHTLY CLOSED IN AN AREA FREE
FROM IGNITION SOURCES. PROTECT FROM MOISTURE. PRODUCT WILL
HYDROLYZE. SEE SUPP DATA.
Other Precautions:DO NOT EXPOSE TO MOISTURE AND HIGH TEMP ENVIRONMENTS
WHICH MAY DETERIORATE PROD.;WATER AT HIGH TEMP CAUSED
HYDROLYSIS;AVOID BREATHG VAP;WASH THOROUGHLY AFTER HANDLING.AVOID
FIRE/IGN CONDITION
* Physical/Chemical Properties *
HCC:V6
Vapor Pres:<1 MM
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR OILEY LIQUID, MILD,SWEET ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS,WATER.
Stability Condition to Avoid:MOISTURE,HIGH TEMPERATURES. SEE SUPP DATA.
Hazardous Decomposition Products:NORMAL PRODUCTS OF HYDROCARBON
COMBUSTION PLUS SILICON DIOXIDE AND PARTIAL SILICATE ESTERS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
MFR SUGGESTS INCINERATION. DO NOT FLUSH TO SEWER OR PUBLIC WATER
WAY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
BREATHING APPARATUS (SCBA).
Ventilation:LOCAL EXHAUST, HOOD; MECHANICAL GENERAL, FAN.
Other Protective Equipment:APPROPRIATE TO PREVENT PROLONGED CONTACT
WITH SKIN.
Work Hygienic Practices:TRAIN PERSONNEL IN SAFE HANDLING OF THIS
PRODUCT.
Supplemental Safety and Health
KEY1:F4.
* Product Identification *
Kit Part:Y
Preparer's Name:HERBERT MOORE
* Composition/Information on Ingredients *
Other REC Limits:NONE SPECIFIED
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE, SKIN AND NOSE
IRRITATION. MAY LEAD TO MUSCULAR WEAKNESS AND DIZZINESS. LONG TERM
EXPOSURE MAY LEAD TO DERMATITIS, LIVER AND KIDNEY DAMAGE.
Effects of Overexposure:EYE, NOSE OR SKIN IRRITATION. HEADACHE AND
NAUSEA WITH IMPAIRED COORDINATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS,
RESPIRATORY TRACT; LIVER OR KIDNEY DISEASE.
* First Aid Measures *
First Aid:EYE CONTACT: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER,
CONTACT PHYSICIAN. SKIN: WASH WITH MILD SOAP & WATER.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.3
Upper Limits:7.1
Extinguishing Media:DRY CHEMICAL, CO2, FOAM, WATER
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS (SCBA)
IN CONFINED AREAS.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND CAN
TRAVEL TO SOURCES OF IGNITION.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. TRANSFER TO SAFETY
CONTAINER, CLEANUP REMAINDER WITH SAND OR SWEEPING COMPOUND. WASH
AREA WITH SOAP & WATER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, WELL VENTILATED AREA.
GROUND CONTAINERS WHEN FILLING OR EMPTYING.
Other Precautions:WASH HANDS BEFORE EATING, DRINKING OR SMOKING, AFTER
HANDLING THIS PRODUCT.
* Physical/Chemical Properties *
HCC:F4
Melt/Freeze Pt:M.P/F.P Text:LIQ @RMTEMP
Vapor Pres:2 MM HG
Vapor Density:3.1(AIR=1)
Spec Gravity:1.5 (WATER=1)
pH:8.5
Evaporation Rate & Reference:2.0 (BUTYL ACETATE = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE PASTE, POLYSULFIDE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT OR OPEN FLAME
Hazardous Decomposition Products:SO2, CO2, H2S, SOOT, CO
* Disposal Considerations *
Waste Disposal Methods:REACT WITH CURING AGENT & DISPOSE AS SOLID
HAZARDOUS WASTE ACCORDING TO LOCAL, STATE & FEDERAL REGULATIONS.
INCINERATION &/OR LAND DISPOSAL, AS IS OR REACT WITH PART B &
DISPOSE AS SOLID HAZARDOUS WAS TE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE SELF-CONTAINED BREATHING APPARATUS IF
PEL/TLV EXCEEDED AS IN A LARGE SPILL OR CONFINED AREA.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER
Work Hygienic Practices:USE GOOD PERSONAL HYGENE. LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
Product ID:#2 DIESEL (SUMMER GRADE)
CAGE:0F7P6
CAGE:0F7P6
* Composition/Information on Ingredients *
Ingred Name:COMPLEX MIXTURE OF PARAFFINIC, OELIFINIC, NAPHTHANIC, AND
AROMATIC HYDROCARBONS
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION- CENTRAL NERVOUS
SYTEM EFFECTS. EYES- IRRITATION. SKIN- SEVERE IRRITATION. BURNS AND
BLISTERING. INGESTION- IRRITATION, BURNS, BLISTERING OF MOUTH,
ESOPHAGUS AND STOMACH. CHRONIC: NO NE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:MANUFACTURER STATES POSSIBLE CARCINOGEN
FROM "DIESEL EXHAUST".
Effects of Overexposure:INHALATION: DIZZINESS, DROWSINESS, HEADACHE,
WEAKNESS, LOSS OF APPETITE. EYES: BURNING SENSATION, REDNESS. SKIN:
BURNS, RASH, BLISTERS. INGESTION: BURNING OF MOUTH AND ESOPHAGUS.
NAUSEA, VOMITING, STO MACH PAIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. GET IMMEDIATE MEDICAL ATTENTION. EYES:
CONTAMINATED CLOTHES. WASH WITH SOAP AND WATER. INGESTION: DO NOT
INDUCE VOMITING! SEE DOCTOR. SEE DOCTOR IF ANY SYMPTOMS PERSIST.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:WATER FOG, DRY CHEMICAL, FOAM, SAND, EARTH, OR
CARBON DIOXIDE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. USE WATER FOG TO COOL FIRE EXPOSED CONTAINERS
AND TO DIPERSE VAPORS.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID. DO NOT USE SOLID
STREAM OF WATER. PROTECT FROM STATIC ELECTRICITY; USE PROPER
BONDING AND GROUNDING PROCEDURES.
* Accidental Release Measures *
Spill Release Procedures:ISOLATE AND DENY ENTRY. CONTAIN SPILL. ABSORB
ON SUITABLE MATERIAL, SCOOP UP AND PLACE IN CONTAINER FOR DISPOSAL.
VENTILATE AREA. USE SELF- CONTAINED BREATHING APPARATUS IN CONFINED
AREA. ELIMINATE SO URCES OF IGNITION FROM SPILL AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM HEAT AND IGNITION
Other Precautions:USE ONLY AS A FUEL. NOT FOR USE AS PORTABLE HEATER OR
APPLIANCE FUEL. TOXIC FUMES MAY ACCUMULATE AND CAUSE DEATH.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:NEGLIGIBLE
Vapor Density:>1 (AIR=1)
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PALE YELLOW LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, FLAME AND OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:OXIDES OF CARBON, NITROGEN, AND
SULFUR.
* Disposal Considerations *
Waste Disposal Methods:IF DISCARDED IN ORIGINAL FORM, DISPOSE OF AS AN
ENVIRONMENTAL MANAGER AND DISPOSE OF IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIO NS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:HOOD.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:PATIENT IS HAVING DFCLTY BRTHG. IF PATIENT HAS STOPPED
BRTHG ADMIN ARTF RESP. IF PATIENT IS IN CARD ARREST ADMIN CPR.
CONTINUE LIFE SUPPORTING MEASURES UNTIL MED ASSISTANCE HAS ARRIVED.
GET MED ATTN IF NEC. DO NOT WEAR SHOES/CLTHG UNTIL ABSOLUTELY FREE
OF ALL CHEMICAL ODORS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:BUTYRIC ACID, ETHYL ESTER; (BUTANOIC ACID ETHYL ESTER)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT LENSES SHOULD NOT BE WORN IN
THE LABORATORY. ALL CHEMICALS SHOULD BE CONSIDERED HAZARDOUS-AVOID
DIRECT PHYSICAL CONTACT! ACUTE:CAN BE HARMFUL IF INHALED. CAN BE
HARMFUL IF SWALLOWED. CAN BE HA RMFUL IF ABSORBED THROUGH THE SKIN.
CANCAUSE EYE IRRITATION. DUST AND/OR VAPORS CAN CAUSE
IRRITATION(EFTS OF OVEREEXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:TO RESPIRATORY TRACT. CAN BE
IRRITATING TO MUCOUS MEMBRANES. CAN CAUSE SKIN IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:ANTIDOTE IS SUBSTANCE INTENDED TO COUNTERACT EFT OF A POIS.
IT SHOULD ADMIN ONLY BY PHYS/TRAINED EMER PERS. MED ADVICE CAN BE
OBTAINED FROM A POIS CTL CTR. INGEST:CALL MD IMMEDIATELY .
TO CLEANSE SKIN. INHAL:REMOVE PATIENT TO FRESH AIR. ADMIN OXYG IF
(SUPDAT)
* Fire Fighting Measures *
Extinguishing Media:FLAMMABLE. CARBON DIOXIDE, DRY CHEMICAL POWDER OR
WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS IS A FLAMMABLE CHEMICAL.
* Accidental Release Measures *
Spill Release Procedures:EVAC AREA. WEAR APPROP OSHA-REGULATED EQUIP.
VENTILATE AREA. SWEEP UP & PLACE IN AN APPROP CNTNR. HOLD FOR
DISPOSAL. WASH CONTAMD SURFACES TO REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE APPROP NIOSH/MSHA APPRVD SFTY
EQUIP. AVOID CONT W/SKIN, EYES & CLTHG. KEEP TIGHTLY CLSD & STORE
IN COOL DRY PLACE. STORE ONLY W/COMPAT CHEMICALS.
Other Precautions:PERSONS NOT SPECIFICALLY & PROPERLY TRAINED SHOULD
NOT HNDL THIS CHEM/ITS CNTNR. THIS PROD IS FURNISHED FOR LAB USE
ONLY! OUR PRODS MAY NOT BE USED AS DRUGS, COSMETICS,
AGRICULTURAL/PESTICIDAL PRODS, FOOD ADDITIVES/AS HOUSEHOLD
CHEMICALS.
* Physical/Chemical Properties *
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:VERY SLIGHTLY SOL
Appearance and Odor:COLORLESS LIQUID; FRUITY, PERFUME LIKE, OR PLEASANT
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES, STRONG ACIDS.
Stability Condition to Avoid:FLAMMABLE. SENSITIVE TO HEAT.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
* Disposal Considerations *
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. DISPOSAL MUST BE I/A/W FEDERAL, STATE &
LOCAL REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST IS PREFERRED TO KEEP VAP/PARTICULATES BELOW
THE TLV VALUE. MECHANICAL AREAWIDE VENTILATION IS ACCEPTABLE.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PROD: CARBON DIOXIDE, CARBON MONOXIDE, WATER VAP, OXIDES OF
NITROGEN/WIDE VARIETY OF INNOCUOUS/TOX FUMES. WASTE DISP METH: NOT
BE CLASSIFIED AS A HAZ WASTE UNDER U.S. FED REGS IN EFT AT THE
TIME THIS MSDS WAS CREATED.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SILICATE, PORTLAND CEMENT; (PORTLAND CEMENT)
Ingred Name:CARBON BLACK
Fraction by Wt: 1%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:SILICA GEL; (SILICON DIOXIDE SAND)
OSHA PEL:6 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: HAZARDOUS IF
INHALED. EYE/SKIN: CAUSES MINOR IRRITATION. CHRONIC: LONG TERM
OVEREXPOSURE TO THE HAZARDOUS MATERIALS IN THIS PRODUCT HAVE BEEN
ASSOCIATED WITH DERMATITIS. CUMULATIVE LUNG DAMAGE. TARGET ORGANS:
EYES, RESPIRATORY SYSTEM, SKIN, LUNGS.
Explanation of Carcinogenicity:CARBON BLACK: IARC MONO ON THE
Effects of Overexposure:IRRITATION, MUCOUS MEMBRANE IRRITATION,
COUGHING, POSSIBLE CHEMICAL BURN.
Medical Cond Aggravated by Exposure:DERMATITIS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING GIVE
ARTIFICIAL RESPIRATION, PREFERABLY MOUTH-TO-MOUTH. IF BREATHING IS
DIFFICULT GIVE OXYGEN. CALL MD. EYES: IMMEDIATELY FLUSH WITH PLENTY
COPIOUS AMOUNTS OF WATER. SEE MD . INGESTION: CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN TO MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP MATERIAL USING SWEEPING COMPOUND AND
PACKAGE THE SOLID PRODUCT IN STEEL DRUMS WHICH ARE IN GOOD
CONDITION. THOROUGHLY CLEAN AREA WHERE SPILL OCCURRED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
FROM SUNLIGHT AND ANY SOURCE OF HEAT. KEEP CONTAINER TIGHTLY CLOSED
WHEN NOT BEING USED.
Other Precautions:USE WITH ADEQUATE VENTILATION. AVOID PROLONGED OR
REPEATED BREATHING OF VAPORS. AVOID SKIN CONTACT.
* Physical/Chemical Properties *
Solubility in Water:0.1%
Appearance and Odor:COLORED POWDER WITH NO ODOR
Percent Volatiles by Volume:0.0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:UNKNOWN DUE TO COMPLEX NATURE OF THIS
MATL. FUMES FROM COMPLETE/INCOMPLETE COMBUST OF THIS MATL MAY INCL
(SUP DAT)
* Disposal Considerations *
Waste Disposal Methods:DISP OF I/A/W FED, STATE, & LOC RULES. BE AWARE
THAT STATE & LOC REQS MAY DIFFER WIDELY DEPENDING ON LOCATION & MAY
IN MANY CASES BE DIFFERENT FROM FED RULES. WHEN INTENDING TO DISP
OF THIS MATL, THE USER IS ADVISED THAT THIS PROD WOULD (SUP DAT)
| 1 | gloves_mandatory |
Control Measures
*
Cage: 0S4B8
*
Contractor Summary
*
Cage: 0S4B8
*
Ingredients
*
Ozone Depleting Chemical: 1
------------------------------
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:CAUSES EYE IRRIT. HARMFUL IF SWALLOWED. CAUSES SKIN
IRRIT. MAY AFFECT BRAIN/NERV SYS, CAUSING DIZZ, HDCH/NAUS. HARMFUL IF
INHALED. OTHER EFTS OF OVEREXP MAY INCL:ANESTH, INTOX, IRREG HEARTBEAT,
NARCOSIS, UNCON. CHRONIC:RPTD OVEREXP TO THIS PROD MAY CAUSE CNS DMG, CARDIAC
ABNORMS. NOTICE:REPORTS (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:HAVE ASSOC RPTD & PRLNG
OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG. INTENTIONAL MISUSE BY DELIB
CONC & INHALING CONTENTS OF THIS PACKAGE MAY BE HARMFUL/FATAL.
CHLOROCARBON MATLS HAVE PRDCD SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB
ANIMALS & COULD HAVE SIMILAR EFT IN HUMANS. ADRENOMIMETICS (E.G., (SUPP
DATA)
First Aid: SKIN:REMOVE CONTAMINATED CLOTHING & WASH BEFORE REUSE. REMOVE
& DESTROY CONTAMINATED SHOES. WASH W/SOAP & WATER. EYE:FLUSH W/WATER
ARTIFICIAL RESPIRATION, PREFERABLY MOUTH-TO-MOUTH. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. GET MEDICAL ATTENTION. INGEST:GET MEDICAL ATTENTION IMMEDIATELY.
*
Handling and Disposal
*
Spill Release Procedures: WEAR APPROP SAFETY EQUIP AS LISTED IN SAFE HNDLG
& USE INFO SECTION. ABSORB ON INERT MATL & DISP OF AS IN WASTE DISP
METHS. WARNING:THIS PROD CONTAINS 1,1,1-TRICHLOROETHANE, WHICH HARMS PUBLIC
HLTH & ENVIRON BY DESTROYING OZONE IN UPPER ATMSOPHERE.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
REGULATIONS. INCINERATION IS THE PREFERRED METHOD OF DISPOSAL.
Handling And Storage Precautions: KEEP CNTNRS CLSD WHEN NOT IN USE. STORE AWAY
FROM IGNIT SOURCES. STORE IN CLEAN, DRY AREA. DO NOT STORE IN ALUMINUM. ALL
EQUIP SHOULD BE GROUNDED.
Other Precautions: STORE IN WELL-VENTILATED AREA. ALL PRECS MUST BE OBSERVED.
NO SMOKING IN AREA OF USE. DO NOT USE IN THE GEN VICINITY OF ARC WELDING,
OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV RADIA MAY CAUSE THE FORMA TION
OF HCL &/OR PHOSGENE (FP N).
*
Fire and Explosion Hazard Information
*
Lower Limits: 7.5%
Extinguishing Media: MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA &
FULL PROTECTIVE EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: THERMAL DECOMPOSITION PRODUCTS MAY INCLUDE HCL
& PHOSGENE (FP N).
*
*
Respiratory Protection: WEAR AN APPROPRIATE, PROPERLY FITTED NIOSH/MSHA
APPROVED RESPIRATOR DURING APPLICATION & HANDLING WHERE VAPOR/MIST ARE
ENCOUNTERED IN BREATHING ZONE. FOLLOW RESPIRATOR MFR'S RECOMMENDATION FOR
SELECTI ON & USE.
Ventilation: SUFFICIENT VENT MUST BE PROVIDED TO MAINTAIN AIRBORNE
CONCENTRATIONS BELOW TLV, PEL & LEL LIMITS.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N). RUBBER APRON SHOULD BE WORN.
Work Hygienic Practices: GOOD PERSONAL HYGIENE PRACTICES ARE REQD AT ALL TIMES
WHEN HNDLG CHEMS. THESE PRACTICES INCL, BUT ARE NOT LTD (SUPDAT)
Supplemental Safety and Health: EFTS OF OVEREXP:EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY
EACH SHIFT/WHEN GOING ON BREAKS & ESP IF CONTAM OCCURS.
*
Physical/Chemical Properties
*
Vapor Pres: SEE ING
Vapor Density: HVR/AIR
Spec Gravity: 1.3
Evaporation Rate & Reference: SLOWER THAN ETHER
Appearance and Odor: LIQUID.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: OPEN FLAME, HEAT, SPARKS.
Materials To Avoid: ZINC, WATER, ALUMINUM.
Hazardous Decomposition Products: HYDROGEN CHLORIDE, PHOSGENE, CHLORINE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Cage: 0S4B8
Company Name: CROWN METRO AEROSPACE COATINGS INC SUB OF DEXTER CORP THE
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:INHALATION OF VAPORS MAY CONTRIBUTE TO THE
OCCURRENCE OF IRREGULAR HEARTBEAT (FP N). CAUSES EYE IRRITATION. HARMFUL IF
SWALLOWED. CAUSES SKIN IRRITATION. MAY AFFECT BRAIN OR NERVOUS SYSTEM, CAUS
ING DIZZINESS, HEADACHE OR NAUSEA. HARMFUL IF INHALED. OTHER EFFECTS OF
OVEREXPOSURE MAY INCLUDE:ANESTHESIA, INTOXICATION, IRREGULAR HEARTBEAT,
NARCOSIS, UNCONSCIOUSNESS. CHRONIC:REPEATED OVEREXPOSURE TO THIS PRODUCT MAY
CAUSE CENTRAL NERVOUS SYSTEM DAMAGE, CARDIAC ABNORMALITIES. NOTICE:REPORTS
HAVE ASSOCIATED REPEATED AND PROLONGED OVEREXPOSURE TO SOLVENTS WITH
PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED. USE NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NORMAL, AMBIENT ATMOSPHERE ACCEPTABLE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART #: KEYBOARD CLEANER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WATER; (DEIONIZED WATER)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ISOPROPYL ALCOHOL; (ISOPROPANOL FRAGRANCE)
Fraction by Wt: 7.5%
Ingred Name:FRAGRANCE
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LAUROAMPHODIACETATE
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 7.4%
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: LITTLE, IF ANY, AFFECTS CAUSED
BY INHALATION OF VAPORS FROM THIS PRODUCT. EYES: MODERATE TO SEVERE
IRRITANT. SKIN: PRODUCT IS MILD IRRITANT. DEFATTING POSSIBLE W/USE.
INGEST: NAUSEA AND DIARRHE A.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. IF BRTHG HAS STOPPED, ADMINISTER
WATER. IF IRRIT PERSISTS, SEEK MED ATTN. SKIN: WASH W/SOAP & WATER.
INGEST: INDUCE VOMIT W/2 GLASSES OF TEPID SALT WATER & FINGER DOWN
THROAT. SEEK MED ATTN. NOTE: ADRENALIN & OTHER SIMILAR CARDIAC
STIMULANTS SHOULD NOT BE USED TO TREAT EFTS OF OVEREXP TO PROD.
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:WATER, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:ABSORB ON APPROPRIATE MATERIAL. PLACE IN
SEALED CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP THIS AND ALL CHEMICALS OUT OF
REACH OF CHILDREN. THIS PRODUCT FOR INDUSTRIAL USE ONLY.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
pH:7
Appearance and Odor:CLEAR WATER-WHITE LIQUID WITH PLEASANT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REACTIVE ALKALI METALS, STRONG ACIDS AND BASES.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:FORCED COMBUSTION YIELDS CARBON
OXIDES.
* Disposal Considerations *
Waste Disposal Methods:MATERIAL MAY BE DISPOSED OF BY A LICENSED
RECLAIMER OR INCINERATION FACILITY. CONSULT LOCAL, STATE, AND
FEDERAL DISPOSAL AUTHORITIES FOR APPROVED PROCEDURES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:IMPERVIOUS CLOTHING & EQUIPMENT;EYEWASH
FOUNTAIN.
Work Hygienic Practices:N/K
Supplemental Safety and Health
SOLV SOL:SOL IN ALCOHOLS,ACETONE.ODOR THRESHOLD:1 PPM.FIRE FIGHT
PROC:HOSE HOLDER/MONITOR NOZZLES OR LEAVE,LET BURN.LEAVE IMMED IF
RISING SOUND FROM VENT/TANK DISCOLORATION.APPLY WATER FROM FAR
DIST,A VOID VAP,KEEP UPWIND.MATL TO AVOID:STRONG OXIDIZERS.TOX
RXN-HCL.METHANOL:EXPLO RXN-CALCIUM CARBIDE,CYANURIC (SEE ING 5)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:FORMIC ACID (SARA III)
Other REC Limits:N/K
OSHA PEL:5 PPM
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
Other REC Limits:N/K
Ingred Name:WATER
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MATL TO AVOID:CHLORIDE,MG,NI,CHLOROFORM & SODIUM
HYDROXIDE,BERYLLIUM HYDRIDE,BROMINE,CHROMIC ANHYDRIDE,STRONG
OXIDIZERS.
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FORMALDEHYDE (SARA III)
Other REC Limits:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:FORMALDEHYDE:OCULAR DAMAGE,VISION
LOSS,DERMATITIS,LIVER/KIDNEY DAMAGE,SECONDARY
STERILIZATION,DEATH,LACRIMATION,PULMONARY
EDEMA,PNEUMONITIS.METHANOL:BLINDNESS W/ OPTIC
NEURITIS,DERMATITIS,SKIN ABSORPT ION,LIVER/KIDNEY
DAMAGE,CEREBRAL/PULMONARY EDEMA,DEATH.FORMIC ACID IS CORROSIVE.
Explanation of Carcinogenicity:FORMALDEHYDE:LIM EVID FOR CARC IN
Effects of
Overexposure:FORMALDEHYDE:EYES:CORR,IRRIT,BLINDNESS.SKIN:CORR,SENSI
T,NARCTC,TOX,BURNS.INGEST:NARCTC,NAUS,VOMIT,PAIN,UNCON,CONVL.INHAL:
CORR,NARCTC,TOX,IRRIT,BRTHG
DFCLTY,LACRIMATION.METHANOL:EYES:LESIONS,CONJ.SKIN:
ECZEMA,DERMAT,ABSORBED-NARCOSIS,VISUAL
IMPAIRMENT.INGEST/INHAL:BLINDNESS W/ OPTIC
NEURITIS,NARCOSIS,INCOOR,PAIN,NAUS.
Medical Cond Aggravated by Exposure:N/K
* First Aid Measures *
MINUTES .SKIN:N/K .INGESTION:CALL MD IMMEDIATELY .INHALATION:REMOVE
TO FRESH AIR.SUPPORT BREATHING (GIVE O*2/ARTIFICIAL RE SPIRATION)
.ANTIDOTE:NO SPECIFIC ANTIDOTE.TREAT SYMPTOMATICALLY AND
SUPPORTIVELY.
* Fire Fighting Measures *
Flash Point Method:CC
Upper Limits:7%
Extinguishing Media:DRY CHEM,CO*2,H*2O SPRAY,FOAM.LRG
FIRE-SPRAY,FOG,ALCOHOL FOAM.EXTING ONLY IF FLOW STOPS;FLOOD W/ H*2O
FOG;STREAM INEFT.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA,FULL PROT EQUIP
.REMOVE CONTR IF POSS/COOL W/ H*2O FROM SIDE UNTIL WELL AFTER FIRE
OUT.FOR MASSIVE FIRE USE UNMANNED (SUP DAT)
Unusual Fire/Explosion Hazard:MOD FIRE/EXPLO HAZ NEAR HEAT/FLAME.VAP
HEAVY (>AIR),TRAVEL LONG DIST,IGNITE & FLASH BACK.VAP-AIR MIX EXPLO
ABOVE FL PT.FORMALDEHYDE+OTHERS YIELDS EXPLO CMPDS.
* Accidental Release Measures *
Spill Release Procedures:SHUT OFF IGNIT SOURCES.DO NOT TOUCH.STOP
LEAK.REDUCE VAP W/ WATER SPRAY.DO NOT GET WATER IN CONTR.TAKE UP W/
SAND,OTHER;PLACE IN CONTR.LARGER-DIKE AHEAD OF SPILL.NO
SMKNG,FLAMES,FLARES.KEEP PEOPLE AWA Y.ISOLATE AREA/DENY ENTRY.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:N/K
Other Precautions:N/K
* Physical/Chemical Properties *
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
pH:2.8-4
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID WITH A PUNGENT ODOR.
* Stability and Reactivity Data *
FORMALDEHYDE:EXPLO RXN-NITROMETHANE,PEROXYFORMIC/PERCHLORIC ACID,MG
CARBONATE,NO*2,HYDROGEN PEROXIDE,ANILINE,(SEE SUPP)
Stability Condition to Avoid:COLD,AIR SENSITIVE.IGNITE BY
HEAT,SPK,FLAME;CONTR EXPLODE IN FIRE.VAP EXPLO HAZ IN/OUTSIDE,IN
SEWER (FIRE/EXPLO HAZ).
Hazardous Decomposition Products:OXYGEN FROM AIR CAN OXIDIZE
FORMALDEHYDE TO FORMIC ACID,ESP WHEN HEATED.FORMIC ACID IS
CORROSIVE.
Conditions to Avoid Polymerization:FORMALDEHYDE TO PARAFORMALDEHYDE
(NON-HAZ).WILL POLYMERIZE W/ ACTIVE ORGANIC MATL (PHENOL) W/ SUDDEN
PRESS DEVELOPMENT.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN CONFINED AREAS & WHEN SPRAYING, NIOSH/MSHA
APPROVED RESPIRATORY DEVICE.
Ventilation:PROPER VENTILATION.
Other Protective Equipment:NONE NEEDED UNLESS SPECIAL EQUIPMENT
DESIRED.
Work Hygienic Practices:WASH HANDS AFTER USE, BEFORE EATING OR USING
WASHROOM.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CARBON BLACK
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Fraction by Wt: <5%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)
HEAVY NAPHTHENIC.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: AMMONIA, FORMALDEHYDE/RESIDUAL
MONOMER VAPORS MAY BE IRRITATING TO EYES, SKIN, MUCOUS MEMBRANES,
RESPIRATORY TRACT & MAY PRODUCE SYMPTOMS OF HEADACHE & NAUSEA IN
POORLY VENT AREA. SKIN: PRLNG/R PTD CONTACT W/PAINT MAY CAUSE SKIN
IRRITATION. EYE: DIRECT CONTACT W/PAINT MAY RESULT IN EYE
IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:DO NOT INGEST.
Medical Cond Aggravated by Exposure:ALLERGY OR SKIN SENSITIZATION.
* First Aid Measures *
First Aid:INHAL: MOVE SUBJECT TO FRESH AIR. SUPPORT BREATHING (GIVE
O*2/ARTF RESP) . EYES: IMMEDIATLY FLUSH EYES W/PLENTY OF WATER FOR
DRINK AND CALL MD.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROTECTIVE
EQUIP. WATER MAY BE USED TO COOL CLOSED CNTNRS TO PVNT PRESS
BUILD-UP & POSS EXPLO WHEN EXPOS TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:RECOVER LIQUID WITH ABSORBENT MATERIAL.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID PROLONGED CONTACT WITH SKIN.
* Physical/Chemical Properties *
Vapor Pres:SEE ING 3
Vapor Density:HVR/AIR
Spec Gravity:1.2
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SOLUBLE
Appearance and Odor:VISCOUS LIQUID. MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXTREME TEMPERATURES IN CLOSED CONTAINERS.
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Supplemental Safety and Health
PAINTS FORMULATED W/O LEAD OR MERCURY. THEY AREN'T HAZDOUS
SUBSTANCES UNDER CURRENT DEPARTMENT OF LABOR DEFINITIONS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
* Hazards Identification *
Effects of Overexposure:EYE: PRIMARY IRRITATION.
* First Aid Measures *
First Aid:EYES: FLUSH WITH CLEAN WATER. IF IRRITATION PERSISTS CALL
PHYSICIAN.
* Fire Fighting Measures *
Fire Fighting Procedures:NON-COMBUSTIBLE.
Unusual Fire/Explosion Hazard:NON-COMBUSTIBLE.
* Accidental Release Measures *
Spill Release Procedures:FLUSH WITH WATER. ABSORB WITH SAWDUST OR RAGS.
*Handling and Storage *
Handling and Storage Precautions:DON'T THROW OR DROP CONTAINERS. DON'T
TAKE INTERNALLY. CLOSE CONTAINER AFTER EACH USE. AVOID ES
CONT/PROLONGED SKIN OR BREATHING OF SPRAY MIST.
Other Precautions:KEEP AWAY FROM CHILDREN.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:CONVENTIONAL METHODS IN COMPLIANCE WITH LOCAL,
STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Other Protective Equipment:BRIMMED HAT. SLICKER SUIT IF DESIRED, BUT
NOT NECESSARY
Supplemental Safety and Health
* Product Identification *
Product ID:ALUM
* Composition/Information on Ingredients *
Ingred Name:ALUMINUM SULFATE (SARA III)
OSHA PEL:2 MG/M3
* Hazards Identification *
Effects of Overexposure:SKIN & EYES: IRRITATION & POSSIBLE ACID BURNS.
INGESTION: ORAL& GASTRO-INTESTINAL IRRITATION.
* First Aid Measures *
DOCTOR. INGESTION: GIVE LARGE QUANTITIES OF WATER & INDUCE
VOMITING. INHALATION: REMOVE FROM CONTAMINATED ATMOSPHERE & GIVE
ARTIFICIAL RESP IRATION, IF NECESSARY.
* Fire Fighting Measures *
FORMS & MAY ADD TO THE COMBUSTION PROBLEM
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP & PACKAGE FOR DISPOSAL. FLUSH AREA
WITH WATER. FOR LARGE SPILLS, CONTACT STAUFFER S TECH SEVICE DEPT.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL DRY AREA.
Other Precautions:ON CONTACT WITH MOISTURE, ALUMINUM SULFATE IS READILY
HYDROLYZED TO SULFURIC ACID
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE CRYSTALS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:IF INCINERATION IS THE DISPOSAL METHOD, RESIDUAL
ALUM CAN DECOMPOSE FORMING SULFUR TRIOXIDE FUMES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:REQUIRED IF TLV EXCEEDED. @ CONC ABOVE 1 PPM, A
NIOSH/MSHA APPROVED SCBA ADVISED.
Ventilation:LOC EXHST: USE GEN/LOC EXHST TO MEET TLV REQUIREMENTS.
Other Protective Equipment:EMERGENCY EYE BATH AND DELUGE SHOWER WHICH
MEETS ANSI DESIGN CRITERIA .
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM HYDROXIDE
Fraction by Wt: 1.4%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3, C
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT WITH SKIN OR EYES MAY CAUSE
IRRITATION/BURNS. INGESTION MAY RESULT IN INTESTINAL IRRITATION
WITH BURNS TO MOUTH.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INGEST: IF SWALLOWED, IF CONSCIOUS, IMMED INDUCE VOMIT. EYES:
FLUSH W/WATER. INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE
O*2/ARTF RE SP) .
* Fire Fighting Measures *
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:VENT AREA. CAREFULLY NEUTRALIZE SPILL WITH
DILUTE HCL. FLUSH AREA WITH FLOODING AMOUNTS OF WATER (USE
CAUTION).
Neutralizing Agent:SEE SPILL PROCEDURES.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN CORROSION-PROOF AREA.
Other Precautions:ISOLATE FROM INCOMPATIBLE MATERIALS.
* Physical/Chemical Properties *
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ORGANIC MATERIALS, MOST COMMON METALS, OXIDES OF
NITROGEN, ALUMINUM.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W ALL APPLICABLE FEDERAL, STATE
AND LOCAL ENVIRONMENTAL REGS. EPA HAZ WASTE NUMBER: DOO2 (CORROSIVE
WASTE).
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE
Ventilation:MECHANICAL: ACCEPTABLE
Other Protective Equipment:NONE
Supplemental Safety and Health
* Product Identification *
Product ID:THERMOGRIP GLUE STICKS FOR HOT GLUE GUN
* Composition/Information on Ingredients *
Ingred Name:PARAFFIN WAX
Fraction by Wt: 2%
OSHA PEL:2 MG/M3 (FUME)
* Hazards Identification *
Effects of Overexposure:NONE. AT APPLICATION TEMPERATURE, MAY BLISTER
SKIN.
* First Aid Measures *
First Aid:SKIN AT APPLICATION TEMP: IMMERSE C ONTACTED PART IN WATER.
DON'T ATTEMPT TO PHYSICALLY REMOVE FROM BLISTERED AREA. CONSULT
PHYSICIAN. (THIS ADHESIVE MAY BE SOFTENED BY MINERAL OIL).
* Fire Fighting Measures *
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:AIR MASK
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP OR SCRAPE UP AT APPLICATION
TEMPERATURE.
*Handling and Storage *
Handling and Storage Precautions:AVOID SKIN CONTACT WHEN MATERIAL IS AT
RECOMMENDED APPLICATION TEMPERATURE.
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE
Appearance and Odor:CREAM-COLORED CYLINDRICAL ROD
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:CO, CO2, & OTHER TOXIC FUMES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF AS SANITARY LANDFILL.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:IF AIRBORNE CONTAMINANTS ARE GENERATED WHEN MATL IS
HEATED/HANDLED, SUFFICIENT VENT IN VOL & AIR FLOW PATTERNS (SUP
DAT)
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
VENT: SHOULD BE PROVIDED TO KEEP AIR CONTAMINANT CONCENTRATION LEVELS
BELOW ACCEPTABLE CRITERIA.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MAGNESIUM CARBONATE (MGCO3)
Fraction by Wt: 1-5%
Ingred Name:LIMESTONE
Ingred Name:KAOLIN
Fraction by Wt: 1-5%
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:TALC
ACGIH TLV:2 MG/M3 RDUST
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN ABSORPTION: NOT TOX
CNDTNSOF USE. HOWEVER, IF ALLOWED TO BECOME AIRBORNE, MAY CAUSE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: IRRIT OF NOSE, THROAT & LUNGS. NOT
Medical Cond Aggravated by Exposure:LIMESTONE/TALC: PREEXISTING
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE.
* First Aid Measures *
First Aid:INGESTION: IF ACCIDENTLY SWALLOWED, DILUTE BY DRINKING LARGE
QUANTITIES OF WATER. IMMEDIATELY CONTACT POISON CONTROL CENTER OR
HOSPITAL EMERGENCY ROOM FOR ANY OTHER ADDITIONAL TREATMENT
DIRECTIONS. IN HALATION: REMOVE TO FRESH AIR. EYES: IMMEDIATELY
IRRITATION PERSISTS. SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. SEE
MD .
* Fire Fighting Measures *
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER SHOULD BE USED TO KEEP FIRE-EXPOSED CONTAINERS
COOL.
Unusual Fire/Explosion Hazard:WILL NOT BURN UNLESS WATER HAS
EVAPORATED.
* Accidental Release Measures *
Spill Release Procedures:SWEEP (SCOOP) UP AND REMOVE TO A CHEMICAL
DISPOSAL AREA. PREVENT ENTRY INTO NATURAL BODIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM FREEZING. STORE IN A COOL,
DRY PLACE. KEEP CONTAINERS TIGHTLY CLOSED. AVOID PROLONGED OR
REPEATED BREATHING OF VAPOR.
Other Precautions:HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND
SAFETY PRACTICES. THESE PRACTICES INCLUDE AVOIDING UNNECESSARY
EXPOSURE AND REMOVAL OF THE MATERIAL FROM EYES, SKIN AND CLOTHING.
* Physical/Chemical Properties *
Vapor Density:<1
pH:9.6
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:DISPERSIBLE
Appearance and Odor:TAN PASTE WITH MILD ACRYLIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN TO BORDEN.
Stability Condition to Avoid:NORMALLY STABLE AS DEFINED IN NFPA
Hazardous Decomposition Products:OXIDES OF CARBON.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE, AND
FEDERAL REQUIREMENTS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:NONE REQUIRED
Supplemental Safety and Health
FL PT:FLAME PROJECTION:NONE.
* Product Identification *
Product ID:SOMACA HI SHEEN GLASS CLEANER
Preparer's Name:LAURA E RADEVSKI
* Composition/Information on Ingredients *
Ingred Name:2-BUTOXYETHANOL
Other REC Limits:N/K
Ingred Name:DIACETONE ALCOHOL (4-HYDROXY-4-METHYL-2-PENTANONE)
Other REC Limits:N/K
Ingred Name:PROPANE
Other REC Limits:N/K
Ingred Name:ISOBUTANE (OF PROPANE/ISOBUTANE PROPELLANT BLEND)
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NIOSH STUDIES INDICATE 2-BUTOXYETHANOL
HAS CAUSED REPRODUCTIVE DISORDERS IN LABORATORY ANIMALS (RATS OR
MICE) & MAY HAVE THE POTENTIAL FOR CAUSING SIMILAR DISORDERS IN
HUMANS .
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:MAY IRRITATE ON PROLONGED & REPEATED
CONTACT.SKIN/INGESTION:N/K .INHALATION:PROLONGED EXPOSURE TO
CONCENTRATED VAPOR MAY CAUSE HEADACHES,DIZZINESS,NAUSEA.
Medical Cond Aggravated by Exposure:NONE KNOWN
* First Aid Measures *
IRRITATION PERSISTS,CONTACT A PHYSICIAN.SKIN:N/K .INGESTION:CALL MD
IMMEDIATELY .INHALATION:MOVE VICTIM TO FRESH AIR.RESTORE
RESPIRATION IF NECESSARY.
* Fire Fighting Measures *
Flash Point:SEE SUPP DATA
Extinguishing Media:DRY CHEMICAL,FOAM,CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .WATER SPRAY MAY BE USED TO COOL CANS IN
VICINITY OF FIRE OR EXCESSIVE HEAT.
TO BURST.HAZARDOUS DECOMPOSITION PRODUCTS:THERMAL DECOMP MAY
PRODUCE CARBON DIOXIDE & CARBON MONOXIDE.
* Accidental Release Measures *
Spill Release Procedures:SOAK UP SPILLS WITH INERT AND ABSORBENT
MATERIAL.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT OR OPEN FLAME OR
Other Precautions:KEEP OUT OF REACH OF CHILDREN & PETS.DO NOT
DELIBERATELY INHALE VAPOR OR SPRAY MIST.AVOID CONTACT WITH EYES.
* Physical/Chemical Properties *
Decomp Temp:Decomp Text:N/K
Spec Gravity:ABOUT 1,H*2O=1
Evaporation Rate & Reference:FASTER THAN BUTYL ACETATE
Solubility in Water:MISCIBLE
Appearance and Odor:WHITE FOAM/SLIGHT AMMONIA ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS,ALUMINUM,COPPER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON DIOXIDE & CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .DISPOSE CANS IN
NON-INCINERATED TRASH ONLY.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
* First Aid Measures *
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMIT,BUT DO NOT MAKE
UNCONSCIOUS PERSO N VOMIT.
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
* Physical/Chemical Properties *
HCC:Z3
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMATIC ODOR.
* Stability and Reactivity Data *
STRONG OXIDIZERS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH CHEMICAL CARTRIDGE RESPIRATOR. FOR
SPRAYING USE MECHANICAL PREFILTER. IN CONFINED AREAS USE AIR
SUPPLIED RESPIRATOR.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:EYEWASH FACILITY, SAFETY SHOWER.
Supplemental Safety and Health
MORE INFORMATION ON FILE
* Product Identification *
Preparer's Name:L. A. ELLISON
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM DISTILLATE HYDROTREATED LIGHT SOLVENT
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHYL ISOAMYL KETONE
Fraction by Wt: 5.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TALC
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2.0 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:CRYSTALLINE SILICA
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
Ingred Name:SILICA, AMORPHOUS HYDRATED
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST: GI IRRIT, NAUSEA, VOMITING,
CHEMICAL PNEUMONITIS INHAL: IRRIT. CNS DEPRESSION, (HEADACHE,
DIZZINESS, NAUSEA, CONFUSION). EYE: IRRIT. SKIN: ABSORPTION,
DEFATTING, IRRITATION. CHRONIC: SILICOSIS , LIVER/KIDNEY/BLOOD
INJURY. BRAIN/NS DAMAGE. INHAL: HARMFUL/FATAL.
Explanation of Carcinogenicity:CRYSTALLINE SILICA IS LISTED BY IARC.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS.
* First Aid Measures *
First Aid:INGEST: DONT INDUCE VOMIT. CALL POISON CONTROL/EMERGENCY
ROOM/DR IMMEDIATELY. INHAL: IMMEDIATELY REMOVE TO FRESH AIR. IF
BREATHING STOPPED, GIVE ARTIFICAL RESPIRATION. KEEP WARM & QUIET.
LIFT LIDS. GET MED AID. SKIN: REMOVE CONTAM CLOTHES, WASH BEFORE
REUSE. WASH W/SOAP AND WATER. GET MED AID.
* Fire Fighting Measures *
Lower Limits:1.0
Upper Limits:7.6
Extinguishing Media:CLASS B EXTINGUISHERS (CO2, DRY CHEMICAL, ALCOHOL
FOAM) FOR FLAMMABLE LIQUID. POLYMER FOAM PREFERRED FOR LARGE FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE H2O (FOG NOZZLES
PREFERRED) TO COOL FIRE EXPOSED CONTAINERS, PREVENT PRESSURE
BUILDUP/AUTOIGNITION/EXPLOSION.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY BE HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT. GET MED AID.
* Accidental Release Measures *
Spill Release Procedures:USE RESPIRATOR & FULL PROTECTIVE
CLOTHING/EQUIPMENT. EVACUATE AREA. ELIMINATE IGNITS. DIKE W/INERT
MATERIAL. TRANSFER TO COVERED METAL CONTAINER W/NON-SPARKING TOOLS.
PREVENT SEWER/STREAM/GROUNDWATER CONTAMINATION.
*Handling and Storage *
Other Precautions:DONT WASH OR REUSE EMPTY CONTAINER FOR ANY PURPOSE.
GROUND & BOND CONTAINERS TO RECEIVING CONTAINER. DONT WELD, BRAZE
OR CUT ON EMPTY CONTAINER. NEVER USE PRESSURE TO EMPTY. DRUM IS NOT
A PRESSURE VES SEL.
* Physical/Chemical Properties *
Vapor Density:>AIR.
Spec Gravity:1.2
pH:4-7
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT.
Appearance and Odor:LIQUID, W/SOLVENT ODOR.
Corrosion Rate:NA
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
OF IGNITION.
Hazardous Decomposition Products:SMOKE, CARBON MONOXIDE & CARBON
DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE & LOCAL
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:APPROP FITTED POS PRESS AIR SUPPLIED RESPRTR
SPRAY) RESPRTR (MFR RECOMM--ISOCYANATE VAPOR/MIST). WEAR RESPRTR
FOR MIXING/SPRAYING/TILL VA POR GONE. FOLLOW RESPRTR MFR
DIRECTIONS.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST--SUFF VOL/PATTERN TO
MAINTAIN CONC BELOW LOWEST TLV.
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
URETHANE ACTIVATOR IS PART OF 2 COMPONENT MIX. IT'S INTENDED TO BE
MIXED W/BASE. CONTENTS OF PACKAGE MUST BE BLENDED W/OTHER
COMPONENTS BEFORE PROD USED. BEFORE OPENING PACKAGES, BE SURE YOU
UNDERSTAN D THE WARNING MESSAGES AND LABELS OF ALL COMPONENTS,
SINCE MIX MAY HAVE HAZARDS (ALL ITS PARTS). FOLLOW PRECAUTIONS.
* Product Identification *
Kit Part:Y
Preparer's Name:W A ELLISON
* Composition/Information on Ingredients *
(LFL: 1.7 UFL: 7.6)
Other REC Limits:NONE SPECIFIED
Ingred Name:1,6-HEXANE METHYLENE DIISOCYANATE (RESIN)
Fraction by Wt: <5%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POLYMERIC HEXAMETHYLENE DIISOCYANATE (RESIN)
Other REC Limits:MFR 1 MG/CU.M.
CALCULATED *NEGLIGIBLY PHOTOCHEMICALLY REACTIVE MATERIALS
Other REC Limits:NONE SPECIFIED
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Health Hazards Acute and Chronic:SKIN: IRRIT, SENSITIZATION. REPEAT
OVEREXPOS: RESPTRY SENSITIZATION. REPORTS ASSOCIATE PROLONG/REPEAT
OVEREXPOS TO SOLVENTS W/PERM BRAIN & NERVOUS SYS DAMAGE. MISUSE BY
CONCENTRATING & INHALING CONTEN TS MAY BE HARMFUL/FATAL. INHAL:
LUNG DAMAGE, ALLERGIC RESPIRATORY REACTIONS (MAY BE PERMANENT).
INGEST: MAY BE FATAL.
Effects of Overexposure:INGESTION: GASTROINTESTINAL IRRIT, NAUSEA,
VOMITING. ASPIRATION MAY CAUSE CHEM PNEUMONITIS (CAN BE FATAL).
INHALATION: IRRITATION, SENSITIZATION, ASTHMA-LIKE SYMPTOMS. EYE:
SEVERE IRRITATION. SKIN: PR IMARY SKIN IRRITANT.
* First Aid Measures *
First Aid:INGESTION: DON'T INDUCE VOMITING. CALL POISON CONTROL CTR,
HOSPITAL EMERG ROOM OR DOCTOR IMMED. INHALATION: REMOVE TO FRESH
AIR IMMED. NO BREATHING, GIVE ARTIFICIAL RESPIRATION. KEEP
WARM/QUIET. GET M ED ATTN IMMED. EYE: FLUSH W/LRG AMT OF WATER,
SKIN: REMOVE CONTAM CLOTHING. WASH AREA W/SOAP & WATER. IRRIT
PERSISTS, GET MED ATTN.
* Fire Fighting Measures *
Lower Limits:1.7
Upper Limits:7.6
Extinguishing Media:USE NFPA CLASS B(CO2, ALL PURPOSE DRY CHEMICAL OR
ALCOHOL FOAM) FOR LIQUID FIRES. POLYMER FOAM PREFERRED FOR LARGE
FIRES
Fire Fighting Procedures:USE SCBA. WATER MAY BE INEFFECTIVE, USE TO
COOL CNTNRS(FOG NOZZLE PREFERABLE) TO PREVENT PRESSURE
BUILD-UP&AUTO-IGNITION/EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD. SYMPTOMS MAY
NOT BE IMMEDIATELY APPARENT. GET MEDICAL ATTENTION.
* Accidental Release Measures *
IGNIT SOURCES. DIKE/CONTAIN SPILL W/INERT MAT'L. TRANSFER LIQ TO
COVERED METAL CNTNRS OR REMOVE W/INERT ABSORB. USE NON-SPARKING
TOOLS. NO CONTAM OF STREAM/S EWER/GROUNDWTR W/PROD/USED ABSORB.
*Handling and Storage *
USE. NO PRESSURE TO EMPTY. DRUM NOT PRESSURE VESSEL.
Other Precautions:NO PERSONS W/CHRONIC BREATH PROBLMS/REACTIONS TO
ISOCYANATES. NO BREATH VAPOR SPRAY/MIST. DON'T GET IN EYES/ON
SKIN/CLOTHING. NO SPARKS/FLAME. DON'T REUSE EMPTY CNTNRS. GROUND &
BOND CNTNRS TO RECEIVI NG CNTNR. NO WELD/CUT/BRAZE EMPTY CNTNR.
* Physical/Chemical Properties *
HCC:F3
Vapor Density:> AIR
Spec Gravity:1.1
pH:4-7
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
SOURCES OF IGNITION.
Hazardous Decomposition Products:BURNING, HEATING, WELD/CUT/BRAZE PROD
COATED MATERIALS WILL PRODUCE: SMOKE, CO, CO2, OXIDES OF NITROGEN,
HYDROGEN GAS.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN EPA PERMITTED FACILITY. DON'T
INCINERATE CLOSED CNTNRS. OBSERVE PRECAUTIONS--DISPOSAL OF
FLAMMABLE MAT'L. CONTAM ABSORBENT MAY BE DISPOSED IN HAZARDOUS
WASTE LANDFILL. DISPOSE IN ACCORDA NCE W/FEDERAL, STATE & LOCAL
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:AS REQUIRED TO PREVENT PROLONGED CONTACT.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:COBALT (SARA III)
OSHA PEL:0.1 MG/M3;AS CO
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
Other Precautions:AVOID CONTACT WITH SKIN AND EYES.USE PROPER PERSONAL
PROTECTION.
* Physical/Chemical Properties *
HCC:A2
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Stability Condition to Avoid:NONE NOTED
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL IN ACCORDANCE WITH
LOCAL,STATE,FEDERAL AND DOD REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A NIOSH APPROVED AIR PURIFYING DUST OR MIST
Ventilation:USE ADEQ GENERAL OR LOCAL EXHAUST VENT TO KEEP AIRBORNE
CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
FACESHIELD .
Other Protective Equipment:EMERGENCY EYE WASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA ). WEAR APPROPRIATE PROTECTIVE CLOTHING TO
PREVENT SKIN EXPOSURE.
Supplemental Safety and Health
MATLS TO AVOID: CINNAMALDEHYDE OR ZINC; & REACTS EXPLOSIVELY W/MIXTURE
OF CHLOROFORM & METHANE. CORR TO METALS SUCH AS ALUMINUM, TIN &
ZINC AS WELL AS TO ALLOYS SUCH AS STEEL & MAY CAUSE FORMATION OF
FLAMMABLE HYDROGEN GAS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM HYDROXIDE
OSHA PEL:2 MG/M3
ACGIH STEL:C2 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: CAUSES SEVERE EYE BURNS. SKIN:
CAUSES SKIN BURNS. MAY CAUSE DEEP, PENETRATING ULCERS OF THE SKIN.
INGESTION: HARMFUL IF SWALLOWED. CAUSES GASTROINTESTINAL TRACT
BURNS. CAUSES SEVERE PAIN, NAUSEA,VOMITING, DIARRHEA AND SHOCK.
INHALATION: IRRITATION MAY LEAD TO CHEMICAL PNEUMONITIS AND
PULMONARY EDEMA. CAUSES SEVERE IRRITATION OF UPPER RESPIRATORY
TRACT WITH COUGHING, BURNS, BREATHING DIFFICUL TY AND POSSIBLE
COMA. CHRONIC: PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE
DERMATITIS. TARGET ORGANS: NONE.
Effects of Overexposure:SEE HEALTH HAZARDS.
* First Aid Measures *
OCCASIONALLY LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN:
GET MED AID IMMED. IMMED FLUSH SKIN W/PLENTY OF SOAP & WATER FOR AT
CLTHG IN A MANNER WHICH LIMITS FURTHER EXPOS. INGEST: DO NOT INDUCE
VOMIT. IF VICTIM IS UNCON & ALERT, GIVE 2-4 CUPFULS OF MILK OR
WATER. N EVER GIVE ANYTHING BY MOUTH TO AN UNCON PERSON. GET MED
AID IMMED. INHAL: REMOVE FROM EXPOS TO FRESH AIR IMMED. IF NOT
BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. GET MED AID.
NOTES TO MD: TREAT SYMPTOMATICALLY & SUPPORTIVELY.
* Fire Fighting Measures *
Flash Point:NOT AVAIL
Autoignition Temp:Autoignition Temp Text:N/AV
Lower Limits:NOT AVAIL
Upper Limits:NOT AVAIL
Extinguishing Media:FOR SMALL FIRES, USE DRY CHEMICAL, CARBON DIOXIDE,
WATER SPRAY OR ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER WITH CAUTION AND IN FLOODING AMOUNTS.
Unusual Fire/Explosion Hazard:CONTACT WITH MOISTURE OR WATER MAY
GENERATE SUFFICIENT HEAT TO IGNITE NEARBY COMBUSTIBLE MATERIALS.
(ESTIMATED) HEALTH: 3; FLAMMABILITY: 0; REACTIVITY: 1.
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT AS
INDICATED. VACUUM OR SWEEP UP MATERIAL AND PLACE INTO A SUITABLE
DISPOSAL CONTAINER. AVOID GENERATING DUSTY CONDITIONS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
AREA AWAY FROM INCOMPATIBLE SUBSTANCES. KEEP AWAY FROM STRONG
ACIDS. KEEP AWAY FROM WATER. KEEP AWAY FROM METALS. KEEP AWAY FROM
FLAMMABLE LIQUIDS. KEEP AWAY FROM ORGANIC HALOGENS. CORROSIVES
AREA. HYGROSCOPIC.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. USE WITH ADEQUATE
VENTILATION. DO NOT ALLOW WATER TO GET INTO THE CONTAINER BECAUSE
OF VIOLENT REACTION. DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. DO
NOT INGEST OR I NHALE.
* Physical/Chemical Properties *
Decomp Temp:Decomp Text:NOT AVAIL
Vapor Density:NOT AVAIL
pH:NOT AVAIL
Viscosity:NOT AVAILABLE
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:1 G/0.9 ML WATER
Appearance and Odor:WHITE SOLID; ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
GENERATES LG AMTS OF HEAT WHEN IN CONTACT W/WATER & MAY STEAM &
SPLATTER. REACTS W/MINERAL ACIDS TO FORM CORRESPONDING SALTS;
REACTS W/WEAK ACIDS, GASES LIKE HYDROGEN SULFIDE, SULFUR DIOXIDE &
CARBON DIOXIDE; IGNITED WHEN I
Stability Condition to Avoid:INCOMPATIBLE MATERIALS, MOISTURE, CONTACT
WITH WATER, ACIDS.
Hazardous Decomposition Products:TOXIC FUMES OF SODIUM OXIDE, SODIUM
PEROXIDE FUMES.
* Toxicological Information*
Toxicological Information:CARCINOGENICITY: SODIUM HYDROXIDE - NOT
LISTED BY ACGIH, IARC, NIOSH, NTP OR OSHA. EPIDEMIOLOGY: NO INFO
REPORTED. TERATOGENICITY: NO INFO REPORTED. REPRODUCTIVE EFTS: NO
INFO REPORTED. NEUROTOXICITY: NO INFO REPORTED. MUTAGENICITY:
MUTATION DATA REPORTED. OTHER STUDIES: NO INFO REPORTED.
* Ecological Information *
CHEM IS NOT MOBILE IN SOLID FORM, ALTHOUGH IT ABSORBS MOISTURE VERY
EASILY. ONCE LIQUID, SODIUM HYDROXIDE LEACHES RAPIDLY INTO THE
SOIL, POSSIBLY CONTAMINATING WATER SOURCES. PHYSICAL/CHEMICAL: NO
INFO FOUND. OTHER: NO INFO FOUND.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN MANNER CONSISTENT W/FEDERAL, STATE
& LOCAL REGULATIONS. RCRA D-SERIES MAXIMUM CONCENTRATION OF
CONTAMINANTS: NONE LISTED. RCRA D-SERIES CHRONIC TOXICITY REFERENCE
LEVELS: NONE LISTED. RC RA F-SERIES: NONE LISTED. RCRA P-SERIES:
NONE LISTED. RCRA U-SERIES: NONE LISTED.
* MSDS Transport Information *
Transport Information:US DOT - SHIPPING NAME: SODIUM HYDROXIDE, SOLID.
PACKING GROUP: 2. IATA - SHIPPING NAME: SODIUM HYDROXIDE, SOLID.
* Regulatory Information *
DOES NOT CNTN ANY HAZ AIR POLLUTANTS. THIS MATL DOES NOT CNTN ANY
CLASS 1 OZONE DEPLETORS. THIS MATL DOES NOT CNTN ANY CLASS 2 OZONE
SUBSTANCE UNDER CWA. NONE OF CHEMS IN PROD ARE LISTED AS PRIORITY
POLLUTANTS UNDER CWA. NONE OF CHEMS IN PROD ARE LISTED AS TOX
POLLUTANTS UNDER CWA. OSHA: NONE OF CHEMS IN PROD CONSIDERED
HIGHLY HAZ BY OSHA.
TSCA INVENTORY. HEALTH & SAFETY REPORTING LIST: NONE OF THE
CHEMICALS IN THIS PRODUCT ARE UNDER A CHEMICAL TEST RULE. SECTION
SIGNIFICANT NEW USE RULE: NONE OF THE CHEMICALS IN THIS MATERIAL
HAVE A SNUR UNDER TSCA.
State Regulatory Information:SODIUM HYDROXIDE CAN BE FOUND ON THE
FOLLOWING STATE RIGHT TO KNOW LISTS: CALIFORNIA, NEW JERSEY,
FLORIDA, PENNSYLVANIA, MINNESOTA, MASSACHUSETTS. CALIFORNIA NO
SIGNIFICANT RISK LEVEL: NONE OF THE CHE MICALS IN THIS PRODUCT ARE
LISTED.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY NEEDED.
Ventilation:LOCAL EXHAUST: WORK IN WELL VENTILATED AREA
Other Protective Equipment:USE CLOTHING & EQUIPMENT CONSISTENT WITH
GOOD PESTICIDE HANDLING AND APPLICATION PROCEDURES.
Work Hygienic Practices:DON'T REUSE EMPTY CONTAINERS. WRAP CONTAINER
AND PUT IN TRASH COLLECTION.
Supplemental Safety and Health
* Product Identification *
Product ID:CLEAN CROP AMINE 4 2,4-D HERBICIDE
* Composition/Information on Ingredients *
Ingred Name:DIMETHYLAMINE SALT OF 2,4-DICHLOROPHENOXYACETIC ACID
Ingred Name:INERT INGREDIENTS (TYPE NOT SPECIFIED)
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:WEAKNESS, LETHARGY, ANOREXIA
Explanation of Carcinogenicity:NONE
Effects of Overexposure:WEAKNESS, LETHARGY, ANOREXIA
* First Aid Measures *
GET MEDICAL ATTENTION. SKIN: WASH CONTAMINATED SKIN WITH SOAP &
PLENTY OF WATER. REMOVE CLOTHING & WASH BEFORE REUSE. INHALATION:
NOT LIKELYA PROBLEM. INGESTION: IF SWALLOWED, PROMPTLY INDUCE
VOMITING, BY TOUCHING FINGER TO BACK OF THROAT, & GET MEDICAL HELP.
NO KNOWN ANTIDOTE.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:NOXIOUS FUMES UNDER FIRE CONDITIONS. PRESSURE
DEMAND SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:IF NO OTHER OPTIONS ARE AVAILABLE, WATER
MAY BE USED, BUT DIKING IS REQUIRED TO KEEP CONTAMINATED WATER OUF
OF ALL WATER SOURCES.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILL-SOAK UP WITH ABSORBENT MATERIAL
(CLAY GRANULES, SAWDUST, OR THE EQUIVALENT) & SWEEP INTO DISPOSABLE
CONTAINER. WASH ALL SURFACES WITH WARM WATER AND DETERGENT. DON'T
ALLOW PRODUCT OR WAT ERS TO CONTAMINATE WATER SUPPLIES.
*Handling and Storage *
Handling and Storage Precautions:DON'T USE, POUR, SPILL OR STORE NEAR
FERTILIZERS, FEEDS, OR SEED. KEEP CONTAINER CLOSED. USE WITH
ADEQUATE VENTILATION. DON'T REUSE EMPTY CONTAINER.
Other Precautions:MAY BE HARMFUL IF SWALLOWED. AVOID BREATHING SPRAY
MIST. AVOID CONTACT W/EYES & SKIN. WASH THROUGHLY AFTER HANDLING.
AVOID CONTAMINATION 0F FEED & FOODSTUFFS. DON'T USE ON HOUSEHOLD
PETS OR HUMANS.
* Physical/Chemical Properties *
Spec Gravity:1.6
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:VERY SOLUBLE
Appearance and Odor:DARK COLORED LIQUID WITH MILD AMINE ODOR
Percent Volatiles by Volume:NEGL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NOXIOUS FUMES UNDER FIRE CONDITIONS
Hazardous Decomposition Products:HYDROGEN CHLORIDE, NITROGEN OXIDE,
UNDER FIRE CONDITIONS.
* Disposal Considerations *
Waste Disposal Methods:PESTICIDE WASTE ARE TOXIC. RECYCLING OR
RECONDITIONING, OR PUNCTURE & DISPOSE OF IN A SANITARY LANDFILL, OR
INCINERATION, OR, IF ALLOWED BY STATE & LOCAL AUTHORITIES, BY
BURNING. IF BURNED, STAY OUT O F SMOKE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOS LIM IS EXCEEDED, A NIOSH APPRVD
FULL-FACEPIECE RESP W/ACID GAS CARTRIDGE & DUST/MIST FILTER MAY BE
REGULATORY AGENCY/RESP SUPPLI ER, WHICHEVER IS LOWEST. FOR
EMER/INSTANCES WHERE EXPOS LEVELS ARE NOT KNOWN, USE NIOSH APPRVD
FULL-FACEPIECE POS-PRESS, AIR-SUPPLIED RESP. (SUP DAT)
Ventilation:A SYS OF LOC &/OR GEN EXHST IS REC TO KEEP EMPLOYEE EXPOS
BELOW AIRBORNE EXPOS LIMS. LOC EXHST VENT IS GEN PREF BECAUSE IT
CAN CONTROL EMISSIONS OF (SARA REGS)
FACESHIELD .
Other Protective Equipment:EYEWASH & DELUGE SHOWER MTG ANSI DESIGN
CRITERIA . WEAR IMPERVIOUS PROTECTIVE CLOTHING INCLUDING BOOTS,
SKIN CONTACT.
Work Hygienic Practices:DO NOT GET IN EYES, ON SKIN, OR ON CLOTHING. DO
NOT BREATHE MIST. WASH THOROUGHLY AFTER HANDLING. DO NOT CONTACT
WITH WATER. WASH CLOTHING BEFORE REUSE.
Supplemental Safety and Health
SPILL PROC: US REGS (CERCLA) REQUIRE REPORTING SPILLS & RELEASES TO
SOIL, WATER & AIR IN EXCESS OF REPORTABLE QTYS. THE TOLL FREE
PR OT: WARNING: AIR-PURIFYING RESPS DO NOT PROTECT WORKERS IN
OXYGEN-DEFICIENT ATMOSPHERES.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SULFURIC ACID
Other REC Limits:N/K
OSHA PEL:1 MG/M3
OSHA STEL:N/K
ACGIH TLV:1 MG/M3
ACGIH STEL:3 MG/M3
Ingred Name:WATER
Minumum % Wt:0.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: INHALATION PRODUCES
DAMAGING EFFECTS ON THE MOCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT. SYMPTOMS MAY INCLUDE IRRITATION OF THE NOSE AND THROAT, AND
LABORED BREATHING. MAY CAUSE LUNG EDEM A, A MEDICAL EMERGENCY.
INGESTION: CORROSIVE. SWALLOWING CAN CAUSE SEVERE BURNS OF THE
MOUTH, THROAT, AND STOMACH, LEADING TO DEATH. CAN CAUSE SORE
THROAT, VOMITING, DIARRHEA. CIRCULATORY COLLAPSE WIT H CLAMMY SKIN,
WEAK AND RAPID PULSE, SHALLOW RESPIRATIONS, AND SCANTY URINE MAY
FOLLOW INGESTION OR SKIN CONTACT. CIRCULATORY SHOCK IS OFTEN THE
IMMEDIATE CAUSE OF DEATH. (EFFECTS OF OVEREXPOSURE)
Explanation of Carcinogenicity:SULFURIC ACID (MIST): IARC MONOGRAPHS,
Effects of Overexposure:HEALTH HAZARDS: SKIN: CORROSIVE. SYMPTOMS OF
REDNESS, PAIN, AND SEVERE BURNS CAN OCCUR. CIRCULATORY COLLAPSE
WITH CLAMMY SKIN, WEAK AND RAPID PULSE, SHALLOW RESPIRATIONS, AND
SCANTY URINE MAY FOLLOW S KIN CONTACT OR INGESTION. CIRCULATORY
SHOCK IS OFTEN THE IMMEDIATE CAUSE OF DEATH. EYES: CORROSIVE.
CONTACT CAN CAUSE BLURRED VISION, REDNESS, PAIN AND SEVERE TISSUE
BURNS. CAN CAUSE BLINDNESS. CHRONI C: LONG-TERM EXPOSURE TO MIST OR
VAPOR MAY CAUSE DAMAGE TO TEETH. CHRONIC EXPOSURE TO MISTS
CONTAINING SULFURIC ACID IS A CANCER HAZARD.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THE SUBSTANCE.
* First Aid Measures *
First Aid:IN ALL CASES, CALL MD IMMED. INHAL: REMOVE TO FRESH AIR. IF
NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. CALL MD IMMED. INGEST: DO NOT INDUCE VOMIT.
GIVE LGE QTY S OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. CALL MD IMMED. SKIN: IMMED FLUSH W/PLENTY OF
& SHOES. WASH CLOTHIN G BEFORE REUSE. EXCESS ACID ON SKIN CAN BE
NEUTRALIZED W/2% SOLUTION OF BICARBONATE OF SODA. CALL MD IMMED.
EYES: IMMED FLUSH W/GENTLE BUT LARGE STREAM OF WATER FOR AT LEAST
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, FOAM OR CARBON DIOXIDE. DO NOT USE
WATER ON MATERIAL. HOWEVER, WATER SPRAY MAY BE USED TO KEEP
FIRE-EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . STRUCTURAL FIREFIGHTER'S PROTECTIVE CLOTHING IS
INEFFECTIVE FOR FIRES INVOLVING THIS MATERIAL. STAY AWAY FROM
SEALED CONTAINERS.
Unusual Fire/Explosion Hazard:CONCENTRATED MATERIAL IS A STRONG
DEHYDRATING AGENT. REACTS WITH ORGANIC MATERIALS AND MAY CAUSE
IGNITION OF FINELY DIVIDED MATERIALS ON CONTACT. CONTACT WITH MOST
METALS CAUSES FORMATION OF FLAMMABLE AND EXPLOSIVE HYDROGEN GAS.
* Accidental Release Measures *
Spill Release Procedures:VENT AREA OF LEAK/SPILL. WEAR APPROP PERS PROT
EQUIP AS SPECIFIED IN CTL MEASURES SECTION. ISOLATE HAZ AREA. KEEP
UNNEC & UNPROTECTED PERS FROM ENTERING. CONTAIN & RECOVER LIQ WHEN
POSS. NEUTRALIZE W/ ALKALINE MATL (SODA ASH, LIME), THEN ABSORB
W/INERT MATL (E.G., VERMICULITE, DRY SAND, EARTH), & PLACE IN CHEM
WASTE CONTR. DO NOT USE COMBUST MATLS, SUCH AS SAWDUST. DO NOT
FLUSH TO SEWER! (SUP DAT)
Neutralizing Agent:ALKALINE MATLS (SODA ASH, LIME). J.T. BAKER
NEUTRASORB(TM)/TEAM(TM) 'LOW NA+' ACID NEUTRALIZERS ARE
RECOMMENDED.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED STORAGE
AREA W/ACID RESISTANT FLOORS & GOOD DRAINAGE. PROTECT FROM PHYSICAL
DAMAGE. KEEP OUT OF DIRECT SUNLIGHT & AWAY FROM HEAT, WATER, &
INCOMPATIBLE MATERIALS. DO NOT WASH OUT CONTAINER & USE IT FOR
OTHER PURPOSES. KEEP CONTAINER CLOSED. USE ONLY W/ADEQ VENTILATION.
Other Precautions:WHEN DILUTING, ALWAYS ADD ACID TO WATER; NEVER ADD
WATER TO ACID. WHEN OPENING METAL CONTAINERS, USE NON-SPARKING
TOOLS BECAUSE OF POSSIBILITY OF HYDROGEN GAS BEING PRESENT.
CONTAINERS MAY BE HAZARDOU S WHEN EMPTY SINCE THEY RETAIN PRODUCT
RESIDUES (VAPORS, LIQUID); OBSERVE ALL WARNINGS & PRECAUTIONS
LISTED FOR PRODUCT.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:SEE STATE REGS
Vapor Density:3.4(AIR=1)
Spec Gravity:SEE STATE REGS
pH:SEE STATE REGS
Evaporation Rate & Reference:NO INFORMATION FOUND
Solubility in Water:SEE STATE REGS
Appearance and Odor:CLEAR OILY LIQUID, ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, POTASSIUM CHLORATE, POTASSIUM PERCHLORATE, POTASSIUM
PERMANGANATE, SODIUM, LITHIUM, BASES, ORG MATL, HALOGENS, METAL
ACETYLIDES, OXIDES & HYDRIDES, METALS (YIELDS HYDROGEN GAS), STRONG
OXIDIZING & REDUCING AGENTS & M
Stability Condition to Avoid:HEAT, MOISTURE, INCOMPATIBLES.
CONCENTRATED SOLUTIONS REACT VIOLENTLY WITH WATER, SPATTERING AND
LIBERATING HEAT.
Hazardous Decomposition Products:TOX FUMES OF OXIDES OF SULFUR WHEN
HEATED TO DECOMP. WILL REACT W/WATER OR STEAM TO PRODUCE TOX & CORR
FUMES. REACTS W/CARBONATES TO GENERATE CARBON DIOXIDE GAS, &
W/CYANIDES & SULFIDES TO (HAZ POLYM)
Conditions to Avoid Polymerization:HAZ DECOMP PRODS: FORM POISONOUS
HYDROGEN CYANIDE & HYDROGEN SULFIDE RESPECTIVELY.
* Toxicological Information*
REPRODUCTIVE EFFECTOR. CARCINOGENI CITY: CANCER STATUS: THE
INTERNATIONAL AGENCY FOR RESEARCH ON CANCER (IARC) HAS CLASSIFIED
"STRONG INORGANIC ACID MISTS CONTAINING SULFURIC ACID" AS A KNOWN
HUMAN CARCINOGEN (IARC CATEGORY 1). THIS CL ASSIFICATION APPLIES
ONLY TO MISTS CONTAINING SULFURIC ACID AND NOT TO SULFURIC ACID OR
SULFURIC ACID SOLUTIONS. SULFURIC ACID AND WATER ARE NOT LISTED IN
NTP, OR IARC.
* Ecological Information *
Ecological:ENVIRONMENTAL FATE: WHEN RELEASED INTO THE SOIL, THIS
MATERIAL MAY LEACH INTO GROUNDWATER. WHEN RELEASED INTO THE AIR,
THIS MATERIAL MAY BE REMOVED FROM THE ATMOSPHERE TO A MODERATE
EXTENT BY WET DEPO SITION. WHEN RELEASED INTO THE AIR, THIS
MATERIAL MAY BE REMOVED FROM THE ATMOSPHERE TO A MODERATE EXTENT BY
WATER/CONDITIONS OF BIOASSAY NOT SPECIFIED. THIS MATERIAL MAY BE
TOXIC TO AQUATIC LIFE.
* Disposal Considerations *
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECOVERY/RECYCLING
SHOULD BE HANDLED AS HAZ WASTE & SENT TO RCRA APPRVD
INCINERATOR/DISPOSED IN RCRA APPRVD WASTE FACILITY. PROCESSING,
USE/CONTAMINATION OF PROD MAY CHANG E WASTE MANAGEMENT OPTIONS.
STATE & LOC DISP REGS MAY DIFFER FROM FED DISP REGS. DISPOSE OF
CONTR & UNUSED CONTENTS I/A/W FEDERAL, STATE & LOC REQS.
* MSDS Transport Information *
Transport Information:DOMESTIC (LAND, D.O.T.): PROPER SHIPPING NAME:
INTERNATIONAL (WATER, I.M.O.) : PROPER SHIPPING NAME: SULPHURIC
NFPA RATINGS: HLTH: 3; FLAMM: 0; REACTIVITY: 2; OTHER: WATER
REACTIVE. PROD USE: LABORATORY REAGENT.
* Regulatory Information *
REACTIVITY: YES (PURE/LIQUID). VENTILATION: CONTAMINANT AT ITS
SOURCE, PREVENTING DISPERSION OF IT INTO THE GENERAL WORK AREA.
PLEASE REFER TO ACGIH DOCUMENT, INDUSTRIA L VENTILATION, A MANUAL
OF RECOMMENDED PRACTICES, MOST RECENT EDITION, FOR DETAILS.
IN TSCA, EC, JAPAN, AUSTRALIA, KOREA, DSL. NOT LISTED IN NDSL.
HAZCHEM CODE: 2P. POISON SCHEDULE: NO INFORMATIO N FOUND. WHMIS:
THIS MSDS HAS BEEN PREPATED ACCORDING TO THE HAZARD CRITERIA OF THE
CONTROLLED PRODU CTS REGULATIONS (CPR) AND THE MSDS CONTAINS ALL OF
THE INFORMATION REQUIRED BY THE CPR.
State Regulatory Information:SULFURIC ACID AND WATER ARE LISTED IN THE
STATE OF PHILADELPHIA. PHYSICAL/CHEMICAL PROPERTIES: MELTING POINT:
MISCIBLE; LIBERATES MUCH HE AT.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED DUST MASKS.
Ventilation:VENT MAY BE USED TO CONTROL OR REDUCE AIRBORNE
CONCENTRATIONS.
Other Protective Equipment:NORMAL CLOTHING. DO NOT WEAR CONTACT LENSES
WHEN WORKING WITH THIS PRODUCT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SILICATE, PORTLAND CEMENT
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
OSHA PEL:SEE TABLE Z3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:NUISANCE DUST MAY CAUSE
TEMPORARY BUT REVERSIBLE RESP PROBLEMS. EYES:ABRASIVE ACTION MAY
CAUSE DMG TO OUTER SURFACE OF EYE. MAY CAUSE SEVERE IRRIT WITH
CORNEAL INJURY. SKIN:IN COMBINATION WITH W ATER DERMAL EXPOS MAY
CAUSE SEVERE ALKALI BURNS. INGEST:NOT APPLICABLE. (CHRONIC) RPTD
INHAL OF RESP (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA: GROUP 2A
(IARC),GROUP 2 (NTP)
Effects of Overexposure:HLTH HAZ: SILICA IN EXCESS OF THE TLV OVER
EXTENDED PERIODS CAN RESULT IN IRREVERSIBLE FIBROSIS OF THE LUNGS
(SILICOSIS).
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. EYES: FLUSH WITH COPIOUS AMOUNTS
OF WATER. CALL MD. SKIN: WASH WITH SOAP AND WATER. INGEST: CALL MD
IMMEDIATELY .
* Fire Fighting Measures *
Extinguishing Media:THIS MATL DOES NOT GIVE FL PT BY CONVENTIONAL TEST
METHODS. USE EXTING AGENT SUITABLE FOR TYPE OF SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
* Accidental Release Measures *
Spill Release Procedures:NO SPECIAL PROCEDURES ARE REQUIRED FOR
CLEAN-UP OF SPILLS OR LEAKS OF THIS MATERIAL. SWEEP UP AND RETURN
FOR REUSE OR DISCARD.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM WET DAMP CONDITIONS.
Other Precautions:NONE
* Physical/Chemical Properties *
Solubility in Water:SLIGHT
Appearance and Odor:DARK GRAY GRANULAR POWDER, ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:THIS PRODUCT, WHEN DISCARDED OR DISPOSED OF, IS
NOT LISTED AS A HAZARDOUS WASTE IN FEDERAL REGULATIONS. DISPOSE IN
A LANDFILL IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
Ventilation:USE EXPLO-PROOF VENT EQUIP. USE ADEQ GEN/LOC EXHAUST VENT
TO KEEP AIRBORNE CONCS BELOW PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . WEAR
IMPERVIOUS APRON. WEAR APPROP CLTHG TO PVNT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE CONTAMD
CLOTHING & WASH BEFORE REUSE.
Supplemental Safety and Health
EFTS OF OVEREXP: DISTURB. RPTD EXPOS MAY CAUSE NERV SYS ABNORMAL
W/MUSCLE WEAK & DMG, MOTOR INCOORDINATION, & SENSATION DISTURB.
TARGET ORGANS: HEART, NERV SYS. FIRST AID PROC: IMMED. INHAL:
REMOVE TO FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG
IS DFCLT, GIVE OXYG. GET MED AID. NOTES TO PHYS: (ING 4)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:3-METHYL PENTANE
Fraction by Wt: 4.2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CYCLOPENTANE, METHYL-; (METHYLCYCLOPENTANE)
Fraction by Wt: 9.7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HEXANE; (N-HEXANE) (CERCLA)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SUPDAT: TREAT SYMPTOMATICALLY AND SUPPORTIVELY.
Ingred Name:OTHER PREC: OR INHALE. DO NOT PRESSURIZE, CUT, WELD,
BRAZE,, SOLDER, DRILL, GRIND, OR EXPOSE EMPTY CNTNRS TO (ING 6)
Ingred Name:ING 5: HEAT, SPARKS OR OPEN FLAMES.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: CONT PRODUCES IRRIT,
TEARING, & BURNING PAIN. SKIN: MAY BE ABSORBED THROUGH SKIN IN
HARMFUL AMTS. MAY BE ABSORBED THRU SKIN. CAUSES IRRIT W/BURNING
PAIN, ITCHING, & REDNESS. INGEST: ASPIR HAZARD. MAY CAUSE GI IRRIT
W/NAUS, VOMIT & DIARR. MAY CAUSE EFTS SIMILAR TO THOSE FOR INHAL
EXPOSURE. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: ASPIR CAN CAUSE ASPHYXIA, BRAIN DMG,
& CARD ARREST. EXPOSURE MAY CAUSE CARD SENSITIZ. INHAL: EXPOS
PRODUCES CNS DEPRESS. EXPOS MAY CAUSE DIZZ, HALLUCINATIONS, MUSCLE
WEAK, VISUAL DISTURB, & NERV SYS DISTURB. CHRONIC: PRLNGD/RPTD
EXPOS MAY CAUSE ADVERSE REPROD EFTS. CHRONIC EXPOSURE MAY CAUSE
VISUAL (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW VICTIM
TO RUB/KEEP EYES CLSD. SKIN: GET MED AID IF IRRIT
REMOVE CONTAMD CLTHG & SHOES. INGEST: DO NOT INDUCE VOMIT. IF
VICTIM IS CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. POSS
ASPIR HAZARD. GET MED AID (SUPDAT)
* Fire Fighting Measures *
Lower Limits:1.2%
Upper Limits:7.7%
Extinguishing Media:FOR SM FIRES, USE WATER SPRAY, DRY CHEMICAL, CARBON
DIOXIDE/CHEMICAL FOAM. USE WATER SPRAY TO COOL FIRE-EXPOS CNTNRS.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . USE
WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:VAPS CAN TRAVEL TO SOURCE OF IGNIT &
FLASH BACK. EXTREMELY FLAMM. MATL WILL READILY IGNITE AT ROOM TEMP.
CONTAINERS MAY EXPLODE IN THE HEAT OF A FIRE.
* Accidental Release Measures *
Spill Release Procedures:WEAR NIOSH APPRVD SCBA & APPROP PERSONAL PROT.
SCOOP UP W/NONSPARKING TOOL, THEN PLACE INTO SUITABLE CNTNR FOR
DISP. REMOVE ALL SOURCES OF IGNITION. ABSORB SPILL USING AN
ABSORBENT, NON-COMBUSTIBLE MA TERIAL SUCH AS EARTH, SAND, OR
VERMICULITE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNIT. STORE
IN COOL, DRY, WELL-VENTILATED AREA AWAY FROM INCOMPAT SUBSTANCES.
USE ONLY IN WELL VENTILATED AREA.
Other Precautions:GROUND & BOND CNTNRS WHEN TRANSFERRING MATL. USE
SPK-PROOF TOOLS & EXPLO PROOF EQUIP. EMTPY CNTNR RETAINS PROD
RESIDUE, (LIQ AND/OR VAP), & CAN BE DANGEROUS. AVOID CONT W/HEAT,
SPKS & FLAME. DO NOT GE T ON SKIN/IN EYES. DO NOT INGEST (ING 5)
* Physical/Chemical Properties *
Vapor Pres:5.2 PSIA
Vapor Density:3
Evaporation Rate & Reference:0.3 (N-BUTYL ACETATE =1)
Solubility in Water:NOT KNOWN
Appearance and Odor:LIQUID. MILD GASOLINE TYPE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXYGEN AND STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STABLE @ ROOM TEMP IN CLSD CNTNRS UNDER
NORM STOR & HNDLG CNDTNS. INCOMPATIBLE MATERIALS, IGNITION SOURCES,
EXCESS HEAT.
Hazardous Decomposition Products:OXIDES OF CARBON.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED UNDER NORMAL OPERATIONS. IF THE
PRODUCT HANDLING RESULTS IN CO EXPOSURE, USE AN OSHA APPROVED
AIR-SUPPLIED RESPIRATOR.
Ventilation:LOCAL EXHAUST: PREFERRED. MECHANICAL (GENERAL): ACCEPTABLE.
Other Protective Equipment:METATARSAL SHOES FOR CYLINDER HANDLING
Supplemental Safety and Health
PROVIDED W/A PRESSURE RELIEF DEVICE DESIGNED TO VENT CONTENTS WHEN
THEY ARE EXPOSED TO ELEVATED TEMPS. NEVER WORK ON A PRESSURIZED
SYSTEM.
* Product Identification *
Product ID:CARBON MONOXIDE/HELIUM/OXYGEN/NITROGEN GAS MIXTURE
* Composition/Information on Ingredients *
Ingred Name:CARBON MONOXIDE
Fraction by Wt: 0.2-0.3%
Ingred Name:HELIUM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:OXYGEN (GAS)
Ingred Name:NITROGEN
ACGIH TLV:ASPHYXIANT
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:WARNING: ADMINISTRATION OF LUNG
DIFFUSION MIXTURES MAY BE HAZARDOUS/CONTRAINDICATED. FOR USE ONLY
BY/UNDER THE SUPERVISION OF A LISCENSED PRACTIONER WHO IS
EXPERIENCED IN THE USE & ADMINISTRATION OF L UNG DIFFUSION
MIXTURES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:WARNING: ADMINISTRATION OF LUNG DIFFUSION
MIXTURES MAY BE HAZARDOUS/CONTRAINDICATED.
* First Aid Measures *
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:EVACUATE AREA. IMMEDIATELY DELUGE CONTAINERS
W/WATER SPRAY FROM MAXIMUM DISTANCE UNTIL COOL, THEN MOVE AWAY
CAREFULLY.
Unusual Fire/Explosion Hazard:NO PART OF A CONTAINER SHOULD BE
COMBUSTION. (SEE SUPP)
* Accidental Release Measures *
Spill Release Procedures:SHUT OFF LEAK SAFELY. VENTILATE AREA/REMOVE
LEAKING CONTAINER TO WELL VENTILATED AREA.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM INCOMPATIBLES. CLOSE
VALVE WHEN NOT IN USE/WHEN EMPTY. STORE & USE W/ADEQUATE
VENTILATION. FOR IN VITRO DIAGNOSTIC USE ONLY.
Other Precautions:USE PIPING & EQUIPMENT ADEQUATELY DESIGNED TO W/STAND
PRESSURES TO BE ENCOUNTERED. OPEN VALVE SLOWLY. WHEN 2/MORE
GASES/LIQUIFIED GASES ARE MIXED, THEIR HAZARDOUS PROPERTIES MAY
COMBINE TO CREATE ADDI TIONAL HAZARDS.
* Physical/Chemical Properties *
Vapor Density:(SEE SUPP)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS/ODORLESS GAS AT NORMAL PRESSURE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
FLAMMABLE MATERIALS, OIL, GREASE & COMBUSTIBLES. COMPATABILITY
W/PLASTICS SHOULD BE CONFIRMED PRIOR TO USE.
SOURCES
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:SLOWLY RELEASE INTO OUTDOOR ATMOSPHERE. DISCARD
PRODUCT/RESIDUE/DISPOSABLE CONTAINER/LINER IN AN ENVIRONMENTALLY
ACCEPTABLE MANNER IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR OIL MIST
IF NEEDED.
Ventilation:MECH(GEN)OR LOCAL EXHAUST THAT PROVIDES ADEQUATE
VENTILATION
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
* Product Identification *
Product ID:KLEENOL
* Composition/Information on Ingredients *
Ingred Name:MINERAL SPIRITS (TLV AS OIL MIST)
ACGIH TLV:5MG/CUM(OILMIST
* Hazards Identification *
Effects of Overexposure:NONE NOTED BY MFR. MAY IRRITATE EYES,SKIN &
RESPIRATORY SYSTEM
* First Aid Measures *
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE.
* Fire Fighting Measures *
Extinguishing Media:CO*2,DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA IN FIRES AND IN
CONFINED AREA.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID.AVOID HEAT,
SPARKS,FLAMES.
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION.USE ABSORBENT
MATERIAL LIKE SAND, EARTH,WIPE UP AND RECOVER FOR PROPER DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY AND VENTILATED
AREA.KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:WASH THOROUGHLY AFTER HANDLING.AVOID SKIN AND EYES
CONTACT.AVOID INHALING MIST IF CREATED.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:<1.0
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEG
Appearance and Odor:MINERAL SPIRITS,LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED
Stability Condition to Avoid:HEAT,SPARKS,FLAMES.
Hazardous Decomposition Products:NONE SPECIFIED.MAY GIVE CO AND/OR CO*2
ON COMBUSTION
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), OR IF AIRBORNE DUST IS EXPECTED, USE
NIOSH/MSHA APPROVED DUST RESPIRATOR.
Ventilation:PROVIDE MECHANICAL LOCAL EXHAUST VENTILATION TO PREVENT
RELEASE OF DUST INTO WORK AREA.
Other Protective Equipment:WEAR LONG SLEEVE SHIRT AND SAFETY SHOES.
PROVIDE EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
Product ID:TRISODIUM PHOSPHATE ANHYDROUS
CAGE:0AZD7
* Composition/Information on Ingredients *
Ingred Name:SODIUM PHOSPHATE, TRIBASIC (SARA III)
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE AND SKIN CAUSES IRRITATION.
INHALATION OF HEAVY DUST MAY IRRITATE NOSE AND THROAT. INGESTION
MAY INJURE MOUTH, THROAT, AND GASTROINTESTINAL TRACT. CHRONIC: NO
LONG TERM HUMAN STUDIES HAVE B EEN REPORTED.
Effects of Overexposure:EYE AND SKIN: CAUSES IRRITATION. NO SIGNIFICANT
SKIN ABSORPTION HAZARD. INHALATION: SMALL AMOUNTS OF DUST ARE VERY
IRRITATING. INGESTION: SLIGHT TOXIC.
Medical Cond Aggravated by Exposure:PRE-EXISTING DISEASE INVOLVING THE
EYES, SKIN, OR RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM
EXPOSURE.
* First Aid Measures *
First Aid:EYES; FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH SKIN WITH SOAP
AND WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION.
INHALATION: MOVE TO FR ESH AIR. IF BREATHING DIFFICULTY OR
DISCOMFORT OCCURS AND PERSISTS, GET MEDICAL ATTENTION. INGESTION:
RINSE MOUTH WITH WATER. GIVE 1 OR 2 GLASSES OF WATER.DO NOT INDUCE
VOMITING.GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP WITHOUT CREATING DUST AND RETURN TO
PROCESS, IF POSSIBLE OR PLACE IN SALVAGE CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, VENTILATED AREA.
KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT CONTAINERS
FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE DUST. AVOID
PROLONGED OR REPEATED CONTACT WITH SKIN. WASH THOROUGHLY AFTER
HANDLING. FOR INDUSTRIAL USE ONLY. MATERIAL IS STRONGLY BASIC.
AVOID CONTACT WITH EYES AND SKIN.
* Physical/Chemical Properties *
HCC:B3
Spec Gravity:BULK=1.0G/ML
Appearance and Odor:WHITE GRANULES OR POWDER. NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:MAY BE DISPOSED IN SANITARY LANDFILL IN
ACCORDANCE WITH APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
Ventilation:LOCAL VENTILATION AT THE WORKSITE;MECHANICAL(GENERAL)
VENTILATION TO MAINTAIN TLV/PEL.
Other Protective Equipment:NO SPECIAL REQUIREMENTS.
Work Hygienic Practices:USE REASONABLE CARE IN HANDLING THIS
PRODUCT.WASH HANDS AFTER USE AND BEFORE EATING.
Supplemental Safety and Health
NONE
* Product Identification *
CAGE:0G0J3
CAGE:0G0J3
* Composition/Information on Ingredients *
Ingred Name:VM&P NAPHTHA (LIGROINE)
Fraction by Wt: >8%
Other REC Limits: RECOMMENDED
Fraction by Wt: >5%
Other REC Limits: RECOMMENDED
Fraction by Wt: >5%
Other REC Limits: RECOMMENDED
Ingred Name:VARNISH MAKERS & PAINTER NAPHTHA
Other REC Limits: RECOMMENDED
Other REC Limits: RECOMMENDED
Ingred Name:PROPANE
Other REC Limits: RECOMMENDED
Ingred Name:ISOBUTANE
Other REC Limits: RECOMMENDED
Fraction by Wt: >5%
Other REC Limits: RECOMMENDED
Ingred Name:2-BUTOXYETHANOL
Fraction by Wt: >5%
Other REC Limits: RECOMMENDED
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER
Fraction by Wt: >5%
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST:HARMFUL OR FATAL IF
SWALLOWED.EYES/SKIN:PRIMARY IRRITANT.INHAL:HIGH CONCENTRATONS MAY
CAUSE RESPIRATORY TRACT IRRITATION AND CNS EFFECTS.CHRONIC:MAY
CAUSE PERMANENT BRAIN AND CNS DAMAGE.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:INHAL:ANESTHETIC
EFFECT(DROWSINESS,LIGHTHEADEDNESS,HEADACHE,DIZZINESS,STAGGERING,CON
FUSION).
Medical Cond Aggravated by Exposure: SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
PHYSICIAN.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN OR ARTIFICIAL
RESPIRATION IF NEEDED.INGEST:DO NOT I NDUCE VOMITING.GET PROMPT
QUALIFIED MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:2.3
Extinguishing Media:NFPA CLASS B EXTINGUISHERS:DRY CHEMICAL,CARBON
DIOXIDE,FOAM.WATER IS AN INEFFECTIVE EXTINGUISHANT.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:DECOMPOSTION PRODUCTS MAY BE
TOXIC.CONTAINERS MAY BURST AT ELEVATED TEMPERATURES.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION.USE PROPER
RESPIRATORY AND PROTECTIVE EQUIPMENT.SHUT OFF LEAK IF
SAFE.DIKE.SOAK UP WITH A NON-COMBUSTIBLE INERT
ABSORBANT(CLAY,SAND);PLACE IN PROPER CONTAINER FOR DISPOSA L.WASH
SPILL AREA TO REMOVE SLIPPINESS.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
COOL,DRY,WELL-VENTILATED PLACE.KEEP CONTAINER CLOSED WHEN NOT IN
USE.KEEP AWAY FROM HEAT,SPARKS,FLAMES AND INCOMPATIBLE MATLS.
Other Precautions:FOLLOW LABEL DIRECTIONS.AVOID BREATHING VAPORS.AVOID
SKIN AND EYE CONTACT.USE ONLY NONSPARKING TOOLS.
* Physical/Chemical Properties *
HCC:V3
Vapor Density:>1
Spec Gravity:0.7-0.8
Solubility in Water:MODERATE
Appearance and Odor:AEROSOL PAINT,GREEN,CHARACTERISTIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS,STRONG ALKALIES,STRONG MINERAL ACIDS.
Stability Condition to Avoid:HIGH HEAT,SOURCES OF IGNITION.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A RESPIRATOR RECOMMENDED FOR ORGANIC VAPOR
ENVIRONMENT (AIR PURIFYING OR FRESH AIR SUPPLIED). OBEY OSHA REGS
FOR RESPIRATOR USE. PROVIDE VENT TO KEEP EXPOSURE LEVELS BELOW PEL.
Ventilation:EXHAUST VENT TO KEEP AIRBORNE CONCENTRATIONS BELOW TLV'S.
REMOVE ALL IGNITION SOURCES.
Other Protective Equipment:THE USE OF LONG SLEEVE AND LONG LEG CLOTHING
IS RECOMMENDED. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM. SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
Preparer's Name:NORM GAUL
* Composition/Information on Ingredients *
Ingred Name:ALIPHATIC ISOCYANATE BIURET OF HMDI
Other REC Limits:NONE RECOMMENDED
Ingred Name:HEXAMETHYLENE DIISOCYANATE [HDI] FREE MONOMER >0.5% AT TIME
OF MFR, AFTER 3-6 MO, MAY RISE TO MAX 1.6%.
Fraction by Wt: 0.5-1.6%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: RESP TRACT IRRIT,NERV SYS
DEPRESS (HEADACHE,DIZZY,STAGGER,CONFUSION,UNCONSCIOUS,COMA). SKIN:
ISOCYANATE REACT W/PROTEIN CAUSING IRRIT (SWELL,RED,RASH). ABSORPT:
IRRIT,DRYING,DEFATTING (CRACKING ). EYE: IRRIT (TEAR,RED,SWELL
W/STING).INGEST: IRRIT,CORROSIVE IN GI TRACT. VOMIT MAY CAUSE
ASPIRATION-CHEM PNEUMONITIS
Effects of Overexposure:ACUTE: VAPOR IRRITATING TO EYES, NOSE, THROAT.
INHALATION MAY CAUSE HEADACHES, DIFFICULT BREATHING &
UNCONSCIOUSNESS. CHRONIC: AS RESULT OF PREVIOUS REPEATED
OVEREXPOSURE OR SINGLE LARGE DOSE , SOME WILL DEVELOP ISOCYANATE
SENSITIZATION WHICH WILL CAUSE THEM TO REACT TO LATER ISOCYANATE
EXPOSURE WELL BELOW TLV.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS. ISOCYANATE
SENSITIZATION.
* First Aid Measures *
First Aid:INHAL: MOVE TO FRESH AIR. RESTORE BREATHING. ASTHMATIC TYPE
SYMPTOMS MAY DEVELOP. GET MEDICAL AID. SKIN: REMOVE CONTAMINATED
CLOTHES. WASH AFFECTED AREAS W/SOAP & WATER. WASH CONTAMINATED
CLOTHING BEF ORE REUSE. EYES: FLUSH W/LUKEWARM WATER(LOW PRESSURE)
NOT INDUCE VOMITING. DO NOT GIVE ANYTHING TO AN UNCONSCIOUS PERSON.
GET MED AID.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG,
WATER SPRAY
Fire Fighting Procedures:USE FULL PROTECT CLOTH/FIREFIGHT EQUIP W/SCBA.
WATER MAY BE USED TO COOL CLSD CNTNRS (PREVENT PRESS
BLDUP/AUTOIGNIT/EXPLOS). HDI/IRRIT VAPOR GENERATED BY FIRE.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. KEEP FROM HEAT/IGNIT
SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT. APPLIC TO HOT SURFACE REQ
SPECIAL PRECAUTION. OVEREXPOSURE TO DECOMP PROD-HLTH HZD.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN BLDGS IN COMPLY W/OSHA
STORE IN CLOSED CONTAINERS IN WELL VENTILATED AREA.
Other Precautions:KEEP CONTAINERS TIGHT & UPRIGHT (PREVENT LEAK).
PREVENT PROLONGED VAPOR BREATHING. PROLONGED OVEREXPOSURE MAY CAUSE
ALLERGIC REACTION. AVOID CONTACT WITH SKIN & EYES. DO NOT INGEST.
DON'T HANDLE TILL MFR SFTY PRECAUTIONS READ/UNDERSTOOD.
* Physical/Chemical Properties *
HCC:F3
Vapor Density:>AIR
Viscosity:*
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID WITH SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:CONTACT WITH MOISTURE, MATERIAL WHICH
REACT WITH ISOCYANATES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN, TRACES OF HCN &
HDI.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH FEDERAL,
STATE, & LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY CONTAINERS
MUST BE HANDLED WITH CARE, DUE TO PRODUCT RESIDUE & FLAMMABLE
| 1 | gloves_mandatory |
Control Measures
*
Product ID: SUPER STEAM CONCENTRATE CLEANING COMPOUND (SUPDAT)
Cage: 0FMP6
Proprietary Ind: Y
*
Contractor Summary
*
Cage: 0FMP6
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
MINUTES OF CONTACT, AND CAUSE BURNS.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
PERSISTS, CALL PHYSICIAN. SKIN: WASH WITH COLD RUNNING WATER. INHALATION:
REMOVE FROM EXPOSURE. SUPPORT BREATHING (GIVE ARTIFICIAL RESPIRAT ON/OXYGEN)
(FP N). INGESTION: DRINK LARGE AMOUNTS OF WATER-DO NOT INDUCE VOMITING, THEN
DRINK VINEGAR SOLUTION OR LEMON JUICE. SEE PHYSICIAN.
*
Handling and Disposal
*
Spill Release Procedures: NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
WET VACUUM PICKUP OR WATER FLUSH TO DRAIN. IF LARGE SPILL CLEAN UP IN
ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NONE
Extinguishing Media: USE MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS (FP N).
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
*
*
Respiratory Protection: WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN (FP N).
Ventilation: LOCAL EXHAUST ADEQUATE.
Other Protective Equipment: CAN USE SAFETY APRON.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: TRADE NAME/PART #: SOLVENT DETERGENT,
*
Physical/Chemical Properties
*
HCC: C2
PH: SUPDAT
Solubility in Water: COMPLETE
Appearance and Odor: GREEN WATER LIKE FLUID; ALKALI ODOR.
Percent Volatiles by Volume: 3
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: ACIDS OR OXIDIZERS.
Hazardous Decomposition Products: NONE SPECIFIED BY MANUFACTURER.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Product ID: SUPER STEAM CONCENTRATE CLEANING COMPOUND (SUPDAT)
Cage: 0FMP6
Company Name: DIHOMA CHEMICAL & MFG INC
Street: RT 3
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: None
WILL DEFAT SKIN AFTER 3 MINUTES OF CONTACT, AND CAUSE BURNS. CHRONIC: NONE
LISTED BY MANUFACTURER.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE. KEY1:N1.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:SODIUM SULFITE
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM ERYTHROBATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM METABISULFITE
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY LIBERATE SULFUR DIOXIDE GAS WHICH
IS IRRITATING TO RESPIRATORY TRACT. EXPECTED TO BE A LOW INHALATION
HAZARD. EYE CONTACT MAY CAUSE TRANSIENT IRRITATION. LOW SKIN
CONTACT HAZARD FOR RECOMMENDED HA NDLING. EXPECTED TO BE A LOW
INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:RESPIRATORY TRACT IRRITATION; EYE IRRITATION;
SKIN IRRITATION; WHEEZING, CHEST TIGHTNESS, STOMACH UPSET, HIVES,
FAINTNESS, WEAKNESS, DIARRHEA.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS OR
SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE WHEEZING, CHEST
TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS, WEAKNESS AND DIARRHEA.
* First Aid Measures *
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMEEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Flash Point:COMBUSTIBLESOLID
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSTION PRODUCTS.POWDERED MATERIAL MAY FORM
EXPLOSIVE DUST-AIR MIXTURES.
* Accidental Release Measures *
Spill Release Procedures:COLLECT UP AND PUT IN A SUITABLE CONTAINER.
AVOID GENERATION OF DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER
HANDLING. MINIMIZE DUST GENERATION.
Other Precautions:KEEP AWAY FROM IGNITION SOURCES. REFER TO NFPA
CHEMICAL, DYE, PHARMACEUTICAL, AND PLASTICS INDUSTRIES." KEEP AWAY
FROM OXIDIZING MATERIA LS.
* Physical/Chemical Properties *
HCC:N1
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NEGLIGIBLE
Vapor Density:NOT GIVEN
Spec Gravity:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:OFF-WHITE SOLID, NO ODOR
Percent Volatiles by Volume:NIL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SULFUR DIOXIDE
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VAPORS EXCEED TLV USE SELF CONTAINED ORGANIC
MASK NIOSH APPROVED.
Ventilation:SUFFICIENT TO KEEP WORKROOM CONCENTRATION BELOW TLV
Other Protective Equipment:BARRIER CREAM FOR SENSITIVE SKIN
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
Preparer's Name:RYAN MICKELSON
CAGE:0HZU1
CAGE:0HZU1
* Composition/Information on Ingredients *
Ingred Name:AMMONIA, POLYMER WITH CHLOROETHANE AND FORMALDEHYDE
Minumum % Wt:5.
Ingred Name:ETHANOL
* Hazards Identification *
Effects of Overexposure:INHALATION: REPEATED EXPOSURES MAY CAUSE
IRRITATION TO THE UPPER RESPIRATORY TRACT, AND LIVER OR KIDNEY
EFFECTS. EYES: STRONGLY IRRITATING TO EYES; CORROSIVE. SKIN:
REDNESS, BURNING. CAN LEAD TO SE NSITIZATION WITH REPEATED
EXPOSURE.INGESTION: HARMFUL IF SWALLOWED. CORROSIVE LIQUID.
PRE-EXISTING SKIN OR LUNG ALLERGIES MAY INCREASE THE CHANCE OF
DEVELOPING INCREASED ALLERGY SYMPTOMS FROM THIS PRODUCT.
* First Aid Measures *
First Aid:INHALATION: GET FRESH AIR, IF NECESSARY CALL A PHYSICIAN.
SKIN: WASH WITH MILD SOAP AND WATER, APPLY A MILD CREAM. EYES:
CENTER IM MEDIATELY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:3.3
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR
FOG
Fire Fighting Procedures:AVOID BREATHING SMOKE. USE AIR SUPPLIED RESCUE
EQUIPMENT FOR ENCLOSED AREA. WATER TENDS TO SPREAD BURNING LIQUID
IF LARGE AMOUNTS USED
Unusual Fire/Explosion Hazard:FLAMMABLE. VAPORS MAY IGNITE EXPLOSIVELY
AND/OR CAUSE FLASH FIRES. ELIMINATE SOURCES OF IGNITION. NO
SMOKING. USE ADEQUATE CROSS VENTILATION SUFFICIENT TO REMOVE ODOR
OF SOLVENT AND VAPORS. ELECTRICAL LY GOURND ALL CONTAINERS DURING
TRANSFER
* Accidental Release Measures *
Spill Release Procedures:SMALL QUANTITIES MAY BE ABSORBED INTO AN
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
VENTILATION TO AVOID BREATHING VAPORS WHEN COVER IS REMOVED. GROUND
ALL EQUIPMENT WHEN HANDDLING FLAMMA BLE SOLVENTBORNE MATERIALS.
* Physical/Chemical Properties *
Vapor Density:>AIR
Evaporation Rate & Reference:FASTER THAN N-BUTYLACETAT
Solubility in Water:LIGHTER THAN WATER
Appearance and Odor:BROWN, AMMONIA LIKE ODOR
* Disposal Considerations *
Waste Disposal Methods:MATERIAL IS DESIGNATED AS A HAZARDOUS WASTE
UNTIL ALL SOLVENTS AND VAPORS HAVE EVAPORATED. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS. DRIED
ADHESIVE MAY BE DISPOSED OF AS ORD INARY WASTE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:PROPER ACID CANNISTER TYPE-FULL FACE PIECE(SEE
Ventilation:LOCAL EXH.& MECH.GNL TO MEET TLV.-USE CORR.RESIST.MATERIAL.
Other Protective Equipment:HARD/SOFT HATS,RUBBER SFTY SHOES W/STEEL
TOE,RUBBER APRON.
Supplemental Safety and Health
* Product Identification *
Product ID:BATTERY FLUID,ACID
* Composition/Information on Ingredients *
Ingred Name:SULFURIC ACID (SARA III)
OSHA PEL:1 MG/M3
* Hazards Identification *
Effects of Overexposure:FUMES NOT PRESENT AT AMBIEN TEMPS.LIQUID CAUSES
SEVERE BURNS OF SKIN & EYES.
* First Aid Measures *
PRACTICAL,FLUSH W/LG AMTS OF WTR.REMOVE CLOTHNG IF CONTAMINATED,SEE
DOCTOR/
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:COOL OUTSIDE CONT.W/WTR.DO NOT LET WTR TO
CONTACT ACID.
Unusual Fire/Explosion Hazard:MAY CAUSE FIRE IN CONTACT W/ORG.MTLS.WILL
ATTACK SOME METLS&RELEASE FLAMM&EXPL.H*2 GAS.
* Accidental Release Measures *
Spill Release Procedures:ZONE OFF CONTAM.AREA.NEUTRALIZED W/SODA
ASH,CAUSTIC SODA,LIME,AMMONIA OR OTHER ALK.AGTS.FLUSH AREA
W/LG.AMTS OF WTR FROM SAFE DISTANCE.
*Handling and Storage *
Handling and Storage Precautions:STOR.ONLY IN APPVD TYPE CONT.AVOID
ROUGH HANDLING OF DRUMS.VENT DRUMS WKLY TO RELEASE PRESS.ALWAYS
HAVE WTR SAFETY SHOWERS & EYEWASH STATIONS.
Other Precautions:NO SMOKING REGULATION MUST BE ENFORCED BECAUSE OF
SULFURIC ACID.
* Physical/Chemical Properties *
HCC:C1
Vapor Pres:<1.
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,COLORLESS,SOMETIMES CLOUDY,USUALLY ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
COMBUSTIBLE MTLS&ORGANIC MTLS.
Stability Condition to Avoid:ADDITION OF WATER.
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW ALL GOVERNMENTAL REGS.-SEE MCA
MANUAL,SHEET W-3 ON NEUTRALIZATION OF ACID & ALKALINE PLT
EFFLUENTS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE APPROVED NIOSH RESPIRATORY PROTECTION IF TLV
EXCEEDED, OR OVEREXPOSURE IS LIKELY.
Ventilation:MECHANICAL AND EXHAUST VENTILATION. USE IN WELL VENTILATED
AREA.
Other Protective Equipment:EYEWASH STATIONS
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
THIS PRODUCT CONTAINS METHYLPOLYSILOXANES WHICH CAN GENERATE
CONTAIN OXYGEN. FORMALDEHYDE IS A SKIN AND RESPIRATORY SENSITIZER,
EYE AN D THROAT IRRITANT, ACUTE TOXICANT AND POTENTIAL CANCER
HAZARD. AN MSDS FOR FORMALDEHYDE IS AVAILABLE FROM GE SILICONES.
* Product Identification *
Product ID:SILICONE SEALANT
Preparer's Name:DA POLSINELLI
* Composition/Information on Ingredients *
Ingred Name:TRADE SECRET COMPONENT
Fraction by Wt: 1-5% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT GIVEN
ACGIH TLV:NOT GIVEN
Ingred Name:METHYLTRIACETOXYSILANE
Fraction by Wt: 1-5% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON HAZARDOUS INGREDIENT
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIMETHYL POLYSILOXANE SILANOL/ST
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA GEL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3 TDUST
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL IF SWALLOWED. UNCURED
PRODUCT CONTACT WILL IRRITATE LIPS, GUMS AND TONGUE. UNCURED
PRODUCT CONTACT MAY IRRITATE THE SKIN. CAUSES MODERATE RESPIRATORY
IRRITATION IN UNCURED STATE. UNCURE D PRODUCT CONTACT IRRITATES
EYES. ACETIC ACID RELEASED DURING CURING. CAN GENERATE FORMALDEHYDE
WHICH IS A SENSITIZER.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:LIP IRRITATION, GUM IRRITATION, TONGUE
IRRITATION, SKIN IRRITATION, RESPIRATORY IRRITATION, EYE
IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGESTION: RINSE MOUTH WITH WATER SEVERAL TIMES. SKIN: TO
CLEAN FROM SKIN, REMOVECOMPLETELY WITH A DRY CLOTH OR PAPER TOWEL,
BEFORE WASHING WITH DETERGENT AND WATER. INHALATION: NONE KNOWN.
MINUTES AND GET MEDICAL ATTENTION IF IRRITATION PERSISTS.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:ALL STANDARD FIRE FIGHTING MEDIA
Fire Fighting Procedures:COMBUSTIBLE.
Unusual Fire/Explosion Hazard:SENSITIVITY TO STATIC DISCHARGE IS
* Accidental Release Measures *
Spill Release Procedures:WIPE, SCRAPE OR SOAK UP IN AN INERT MATERIAL
AND PUT IN A CONTAINER FOR DISPOSAL. WASH WALKING SURFACES WITH
DETERGENT AND WATER TO REDUCE SLIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT WITH SKIN AND EYES.
REMOVE CONTACT LENSES BEFORE USING SEALANT. DO NOT HANDLE LENSES
UNTIL ALL SEALANT HAS BEEN CLEANED FROM FINGERTIPS.
Other Precautions:RESIDUAL SEALANT MAY REMAIN ON FINGERS FOR SEVERAL
DAYS AND TRANSFER TO CONTACT LENSES AND CASUE SEVERE EYE
IRRITATION. PRODUCT RELEASES ACETIC ACID DURING APPLICATION AND
CURING. USE IN A WELL VENTIL ATED AREA TO PREVENT IRRITATION.
* Physical/Chemical Properties *
HCC:V7
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Evaporation Rate & Reference:< 1 (BUTYL ACETATE=1)
Solubility in Water:NOT GIVEN
Appearance and Odor:WHITE LIQUID, ACETIC ACID ODOR
Percent Volatiles by Volume:5 %
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPARKS, AND FLAME
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
ACETIC ACID, FORMALDEHYDE
* Disposal Considerations *
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE REQUIRED UNDER NORMAL USE.
Ventilation:NONE REQUIRED UNDER NORMAL USE.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:MINIMIZE BREATHING DUST.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:STYRENE-ACRYLIC COPOLYMER; (2-PROPENOIC ACID, BUTYL ESTER,
POLYMER W/ETHENYL BENZENE) (RESIN)
Ingred Name:STYRENE POLYMER WITH 1,3-BUTADIENE; (BENZENE, ETHENYL-,
POLYMER W/1,3-BUTADIENE) (RESIN)
Ingred Name:BUTANAMIDE, 2,2-((3,3-DICHLORO (1,1-BIPHENYL)-4,4-DIYL)
BIS(AZO)) BIS(N-(2,4-DIMETHYLPHENYL)-3-OXO) (PIGMENT)
Fraction by Wt: 1-5%
Ingred Name:AMMONIUM MOLYBDENUM OXIDE; (ADDITIVE)
Fraction by Wt: <1%
Ingred Name:SILICA GEL; (SILICA) (ADDITIVE)
Fraction by Wt: <1%
OSHA PEL:6 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HEALTH HAZARD IS MINIMAL BEING NEITHER
IRRITATING, CORROSIVE, VOLATILE NOR TOXIC. MUTAGENICITY IS
NEGATIVE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:CONTACT W/EYES MAY RESULT IN MECHANICAL
IRRITATION. INHALATION OF DUST MAY IRRITATE MUCOUS MEMBRANES.
INGESTION MAY RESULT IN GASTRIC DISTURBANCES.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
DEVELS, GET MED ATTN. SKIN:WASH AFFECTED AREAS W/SOAP & WATER. IF
IRRIT DEVELS, GET MED ATTN. REMOVE & LAUNDER CONTAM CLTHG BEFORE
REUSE. IN GEST:IF SWALLOWED DILUTE W/WATER & IMMED INDUCE VOMIT.
GET MED ATTN IF VICTIM IS UNCON/HAVING CONVLS. INHAL:REMOVE TO
FRESH AIR AREA. AID IN BRTHG IF NEC & GET MED ATTN.
* Fire Fighting Measures *
Extinguishing Media:WATER, CO*2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . NOT FLAMM/COMBUST BUT WILL BURN IF IGNITED.
EXTINGUISH W/WATER, CO*2, FOAM OR DRY CHEMICAL.
Unusual Fire/Explosion Hazard:NONE UNDER NORMAL STORAGE & USE
CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:VACUUM OR SWEEP UP DRY POWDER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:AVOID DUST INHALATION & SKIN CONTACT.
Other Precautions:KEEP CONTAINERS CLOSED. STORE IN A COOL, DRY PLACE.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE YELLOW POWDER; PRACTICALLY ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:ABNORMALLY HIGH TEMPERATURE.
Hazardous Decomposition Products:NONE IN NORMALLY HANDLING & USE.
Conditions to Avoid Polymerization:ABNORMALLY HIGH TEMPERATURE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
Control Measures
*
Cage: 0FTT5
*
Preparer Co. when other than Responsible Party Co.
*
Cage: 0FTT5
*
Contractor Summary
*
Cage: 0FTT5
*
Item Description Information
*
Item Manager: GSA
Item Name: ENAMEL
Type/Grade/Class: TYPE I
Unit of Issue: PT
UI Container Qty: 0
Type of Container: METAL
*
Ingredients
*
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
OSHA PEL: 5 PPM
ACGIH TLV: 5 PPM
------------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
-----------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE SPECIFIED
------------------------------
Other REC Limits: NONE SPECIFIED
-----------------------------
Other REC Limits: NONE RECOMMENDED
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CONCENTRATING & INHALING CONTENTS-HARMFUL/ FATAL.
REPEATED & PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS: PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. HIGH VAPOR CONCENTRATIONS: ANESTHETIC.
SKIN & RES P TRACT IRRITATION. OVEREXPOSURE: LIGHTHEADEDNESS, STAGGERING,
GIDDINESS, NAUSEA. HARMFUL IF INGESTED. SEVERE EYE IRRIT
Signs And Symptions Of Overexposure: IRRITATION TO EYES, THROAT AND RESPIRATORY
TRACT. MAY CAUSE HEADACHES, NAUSEA, AND VOMITING.
Medical Cond Aggravated By Exposure: RESPIRATORY AILMENTS
First Aid: FOR CONTACT WITH SKIN OR CLOTHES WASH WITH SOAP AND WATER; WASH
AND CONTACT A PHYSICIAN/OPHTHALMOLOGIST IMMEDIATELY. IF SWA LLOWED, DO NOT
INDUCE VOMITING. GET IMMEDIATE MEDICAL AID. IF INHALED, REMOVE TO FRESH AIR
& GIVE ARTIFICIAL RESPIRATION IF NEEDED. GET MED AID. NEVER GIVE ANYTHING
BY MOUTH TO AN UNCONSCIOUS PERSON.
*
Handling and Disposal
*
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION AND VENTILATE AREA.
MOP SPILLS WITH INERT ABSORBENT. AVOID BREATHING VAPORS.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE &
HEAT/PROLONGED EXPOSURE TO SUN MAY CAUSE CAN TO BUST. DISCARD EMPTY CAN IN
TRASH PICK-UP. DONT PLACE IN HOME TRASHCOMPACTOR.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. CAUTION
BREATHING SPRAY, MIST OR VAPOR.
Other Precautions: AVOID CONTACT WITH EYES OR SKIN. USE WITH GOOD VENTILATION.
READ ENTIRE LABEL BEFORE USING. FOLLOW ALL LABEL DIRECTIONS. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING AND INHALING OR SWALLOWING CON TENTS MAY
BE HARMFUL OR FATAL.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NR
Lower Limits: 1.8
Upper Limits: 9.5
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY.
AVOID SPREADING ANY BURNING LIQUID WITH WATER SPRAY.
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE, USE TO KEEP FIRE EXPOSED
CONTAINERS COOL. WEAR SCBA. USE SHIELDING TO PROTECT PERSONNEL AGAINST
BURSTING, RUPTURING, VENTING OF CNTNR.
Unusual Fire/Explosion Hazard: DO NOT SPRAY NEAR OPEN FLAME. AT ELEVATED
*
*
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
Ventilation: LOCAL EXHAUST PREFERRED. MECHANICAL (GENERAL) ACCEPTABLE AT POINT
OF MIST OR SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN. EYE WASH
STATION.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DO NOT EAT, DRINK OR SMOKE
WHILE USING PRODUCT.
*
Physical/Chemical Properties
*
HCC: V3
Vapor Density: >1.5
Solubility in Water: INSOLUBLE
Appearance and Odor: GRAY/PAINT
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT
Hazardous Decomposition Products: CARBON MONOXIDE
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: PT
Container QTY: 0
Type Of Container: METAL
Additional Data: NONE
*
Detail DOT Information
*
DOT PSN Code: AGC
DOT Proper Shipping Name: AEROSOLS, FLAMMABLE,
DOT PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
Hazard Class: 2.1
Label: FLAMMABLE GAS
Non Bulk Pack: NONE
Bulk Pack: NONE
Vessel Stow Req: A
*
Detail IMO Information
*
IMO PSN Code: AIY
IMO Proper Shipping Name: AEROSOL DISPENSERS ?
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
*
Detail IATA Information
*
IATA PSN Code: ALS
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
*
Detail AFI Information
*
AFI PSN Code: ALR
AFI Symbols: *
AFI Proper Shipping Name: AEROSOLS, FLAMMABLE, N.O.S.
AFI PSN Modifier: (EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.1
Special Provisions: P4
Back Pack Reference: A6.3
*
HAZCOM Label
*
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Label Required IND: Y
Status Code: C
MFG Label NO: UNKNOWN
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: CONCENTRATING & INHALING CONTENTS-HARMFUL/ FATAL.
REPEATED & PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS: PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. HIGH VAPOR CONCENTRATIONS: ANESTHETIC.
SKIN & RES P TRACT IRRITATION. OVEREXPOSURE: LIGHTHEADEDNESS, STAGGERING,
GIDDINESS, NAUSEA. HARMFUL IF INGESTED. SEVERE EYE IRRIT. IRRITATION TO EYES,
THROAT AND RESPIRATORY TRACT. MAY CAUSE HEADACHES, NAUSEA, AND VOMITING.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA
EQUIPMENT. USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:LOCAL EXHAUST: NOT APPLICABLE. MECHANICAL (GENERAL): NOT
APPLICABLE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SUBSTRATE (CYLINDER); (SUBSTRATE) CONTAINING INGREDIENT 2
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALUMINUM DRUM
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COATING; (COATING LAYER CONTAINING INGREDIENTS 4-6)
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BINDER RESIN
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHOTOSENSITIVE MATERIAL
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIGMENT
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: NONE. MINIMALLY
IRRITATING (RABBITS).
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) . EYES:
ASSISTANCE FROM MD . SKIN: FLUSHW/COPIOUS AMOUNTS OF WATER. CALL
MD .
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM AND WATER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . THIS MATERIAL WILL BE SCORCHED IN THE CASE OF FIRE.
Unusual Fire/Explosion Hazard:THIS MATERIAL HAS NO UNUSUAL FIRE OR
EXPLOSION HAZARDS.
* Accidental Release Measures *
Spill Release Procedures:NO SPECIAL PRECAUTIONS.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:NO SPECIAL STORAGE REQUIREMENTS.
Other Precautions:
* Physical/Chemical Properties *
Spec Gravity:2.7 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:REDDISH-BROWN, ODORLESS, SOLID CYLINDER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE, NO*X.
* Disposal Considerations *
Waste Disposal Methods:WASTE MATERIAL MAY BE DUMPED OR INCINERATED
UNDER CONDITIONS WHICH MEET ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED WELD FUME RESPIRATOR OR
AIR-SUPPLIED RESPIRATOR WHEN CUTTING, GRINDING OR WELDING IN
CONFINED SPACES OR WHERE LOCAL EXHAUST OR GENERAL VENTILATION DOES
NOT KEEP EXPOSURE BELOW RECOM MENDED TLV LIMITS.
Ventilation:LOCAL EXHAUST OR GENERAL TO KEEP EXPOSURE BELOW TLV LIMITS
Other Protective Equipment:FACESHIELD, FLAME RETARDANT CLOTHING,
PROVIDE PROTECTIVE SCREENS TO SHIELD OTHERS
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
OSHA PEL:1 MG/CUM (CEILING)
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SOLUBLE) (SUSPECTED HUMAN CARCINOGEN BY NTP, IARC,
ACGIH) INTENDED CHANGE (IC)
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
Ingred Name:SILICON
Fraction by Wt: 4.2%
Ingred Name:ALUMINUM (POWDER)
Fraction by Wt: 1.7%
Ingred Name:IRON
Fraction by Wt: BALANCE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:PRODUCT AS SUPPLIED PRESENTS NO HEALTH
HAZARDS. DUSTS, FUMES, & GASES CAN BE DANGEROUS TO YOUR HEALTH.
CHRONIC EXPOSURE DURING WELDING: LUNG DAMAGE, NEUROLOGICAL DAMAGE,
LUNG FIBROSIS, & OTHER LUNG DI SEASES. ELECTRIC ARC WELDING RAYS
CAN INJURE EYES & BURN SKIN.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION: DIZZINESS, NAUSEA, FEVER, DRYNESS,
WATERY EYES, HEADACHE, BREATHING DIFFICULTY, FREQUENT COUGHING,
CHEST PAINS, & EVEN PULMONARY EDEMA, ASPHYXIATION, & DEATH.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT,
ADMINISTER OXYGEN. IF BREATHING STOPS, BEGIN ARTIFICIAL
RESPIRATION. SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/WATER FOR AT
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Unusual Fire/Explosion Hazard:ARCS, SPARKS & MOLTEN METALS CAN IGNITE
FLAMMABLES & COMBUSTIBLES OR CAUSE EXPLOSION.
* Accidental Release Measures *
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUES &
PLACE IN DOT APPROVED CONTAINERS.
*Handling and Storage *
Other Precautions:AVOID INHALATION & SKIN EXPOSURE. DON'T EXPOSE SKIN
TO RADIATION WHEN HOT CUTTING OR WELDING.
* Physical/Chemical Properties *
Appearance and Odor:SOLID WIRE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:GASES & FUMES FROM INGREDIENTS LISTED
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CONTROLS ARE INADEQUATE, A
NIOSH-APPROVED AIR-SUPPLIED RESPIRATOR SHOULD BE WORN.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE PNI A, SAME NSN. FLASH
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, TEARING, REDNESS, DRYING AND
CRACKING OF SKIN, NAUSEA, VOMITING, COUGHING, HEADACHE, DIZZINESS,
DROWSINESS, WEAKNESS, FATIGUE, UNCONSCIOUSNESS
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS, OR IMPAIRED CNS OR RESPIRATORY FUNCTION
MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
* First Aid Measures *
First Aid:CALL PHYSICIAN IF SYMPTOMS PERSIST. INHALED: MOVE TO FRESH
MINUTES. HOLD EYELIDS OPEN. SKIN: WASH WITH SOAP & WATER. ORAL: DO
NOT INDUC E VOMITING. IF PERSON IS DROWSY/UNCONSCIOUS, PLACE ON
LEFT SIDE WITH HEAD DOWN. GET MEDICAL ATTENTION. IF POSSIBLE, DO
NOT LEAVE INDIVIDUAL UNATTENDED.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:USE CARBON DIOXIDE, SAND, FOAM/DRY CHEMICAL. WATER
SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS WITH FULL FACEPIECE OPERATED IN
POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE AREA.
ABSORB SPILL WITH NON-FLAMMABLE MATERIAL SUCH AS VERMICULITE OR
SAND. PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONT AMINATION. DO NOT FLUSH TO
SEWERS OR WATERWAYS.
Neutralizing Agent:NOT RELEVANT
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA, AWAY
FROM FLAMES & STRONG OXIDIZING AGENTS. KEEP CONTAINER TIGHTLY
CLOSED.
Other Precautions:WARNING! COMBUSTIBLE. KEEP OUT OF REACH OF CHILDREN.
AVOID EYE CONTACT. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY
AFTER HANDLING. EMPTY CONTAINER RETAINS RESIDUE. FOLLOW LABEL
INSTRUCTIONS. AVOID REPEATED SKIN CONTACT.
* Physical/Chemical Properties *
HCC:V4
NRC/State Lic Num:NOT RELEVANT
Viscosity:1.4 CPS
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, WATER WHITE LIQUID - HYDROCARBON ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
VARIOUS HYDROCARBONS
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL IS SUBJECT TO
FEDERAL, STATE OR LOCAL REGULATIONS. REUSING OR INCINERATION IS
RECOMMENDED.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED ORGANIC VAPOR CARTRIDGE
RESPIRATOR W/FULL FACEPIECE FOR EXPOSURE OVER TLV.
Ventilation:GENERAL MECHANICAL VENTILATION IS USUALLY SUFFICIENT TO
KEEP W/TIMEWEIGHTED TLV RANGE.
Other Protective Equipment:APRON & BARRIER CREAM.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:MATERIAL HANDLING POINT.
* Product Identification *
Preparer's Name:THOMAS E. MAREK
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC:INHAL OF LOW CONC OF VAP
CAN CAUSE UPPER RESP IRRIT. INHAL OF HIGH CONC CAN CAUSE DISTURBED
VISION, TREMORS, CARD STRESS, CNS DEPRESS & COMA. RESP DFCLTIES MAY
ALSO BE PRESENT. INHAL OF HIGH CONC HAS RSLTD IN VENTRICULAR
FILLIBRATION & RESP ARREST. SKIN CONT, IS AN IRRIT & CAUSES (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:DEFATTING WHICH LEAD TO DRYNESS,
BLISTERING & DERMATITIS. EYE CONTACT W/LIQUID CAN PRODUCE
CONJUNCTIVITIS & CORNEAL BURNS. SIGNS & SYMPTOMS OF
EXPOSURE:DIZZINESS, BLURRED VISION & REDNESS IN EYES.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY DISORDERS.
* First Aid Measures *
First Aid:SKIN:WASH W/SOAP & WATER IMMEDIATELY AFTER CONTACT. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. EYES:FLUSH W/LARGE
CONTACT MD IF IRRIT PERSISTS. INHAL:REMOVE TO FRESH AIR. RESTORE
BREATHING IF NECESSARY. ADMINISTER OXYGEN IF BREATHING DIFFICULTY
PERSISTS. CONTACT MD. INGEST:CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:0.9
Extinguishing Media:FOAM, DRY CHEMICAL & CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPS ARE HVR THAN AIR & MAY TRAVEL ALONG
GROUND OR BE MOVED BY VENT & IGNITED BY PILOT LIGHTS/OTHER
FLAMES/IGNIT SOURCES AT LOCATIONS DISTANT FROM (SUPP DATA)
* Accidental Release Measures *
Spill Release Procedures:WASH W/WATER INTO RETAINING AREA OR CONTAINER.
AVOID SPARKS, FIRE OR HOT METAL SURFACES. SMALL QUANTITIES MAY BE
ABSORBED ONTO AN APPROPRIATE ABSORBANT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP COOL & AWAY FROM SOURCES OF
IGNITION. USE W/ADEQUATE VENTILATION. AVOID PROLONGED OR REPEATED
PERSONAL CONTACT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:F3
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:9.2 (ETHER=1)
Solubility in Water:NONE
Appearance and Odor:WHITE OR COLORED OPAQUE LIQUID; MILD PETROLEUM
DISTILLATE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE & DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS OR DISPOSE OF
ACCORDING TO APPLICABLE LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A NIOSH/
MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED. CONSULT YOUR
SAFETY OFFICE/INDUSTRIAL HYGIENIST PERSONNEL FOR GUIDANCE FOR THE
TASK AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR INDUSTRIAL HYGIENIST
PERSONNEL.
Work Hygienic Practices:DO NOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS.AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS. WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVE D.
* Product Identification *
Product ID:ASBESTOS SHEET,WOOVEN
Preparer's Name:DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: DUST FROM ABRASIVE ACTIONS MAY
CAUSE EYE, SKIN AND RESPIRATORY IRRITATION. CHRONIC: DUST FROM
ABRASIVE ACTIONS CONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE TO
AIRBORNE FIBERS MAY LEAD TO ASBES TOSIS AND MESOTHELIOMA. SMOKING
COMBINED WITH FIBER INHALATION GREATLY INCREASES LUNG CANCER RISK.
Explanation of Carcinogenicity:ASBESTOS IS LISTED BY AIRC, NTP AND
OSHA.
Effects of Overexposure:INHALATION: COUGHING, WHEEZING, SHORTNESS OF
BREATH, IMPAIRED PULMONARY FUNCTION. SKIN: ITCHING, RASH. EYES:
MECHANICAL IRRITATION FROM AIRBORNE DUST. INGESTION:
GASTROINTESTINAL DISTURBANCES.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING SKIN
OR RESPIRATORY CONDITIONS MAY BE MORE AT RISK FROM EXPOSURE TO
DUSTS OF THIS PRODUCT.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE. SKIN:
WASH EXPOSED AREA WITH SOAP AND WATER. EYES: FLOOD WITH WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTENTION. INGESTION: DRINK WATER.
DO NOT INDUCE VOMITING. SEE DOCTOR. OTHER: CHANGE CLOTHING AS
REQUIRED TO AVOID CARRYING DUST PARTICLES INTO OTHER AREAS.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMCIAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED
WITH AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS
FIBERS TO THE ATMOSPHERE.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED AND BECOME
AIRBORNE.
* Physical/Chemical Properties *
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM NAME".
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FR IABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITIONS;USE
NIOSH/MSHA APPROVED RESPIRATOR AS REQUIRED IF ABOVE PEL/TLV.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE WASH STATION,WORK CLOTHING AND APRON AS
REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
KEY1:V5. THIS IS PART A OF A 2 PART PRODUCT. FOR PART B,SEE PNI B,SAME
NSN.
* Product Identification *
Kit Part:Y
Preparer's Name:SUZANNE FRANZ
* Composition/Information on Ingredients *
Ingred Name:SILICA, AMORPHOUS, DUST
OSHA PEL:6 MG/M3
Ingred Name:ALUMINUM (SARA III)
Ingred Name:4-GLYCIDYLOXY-N,N-DIGLYCIDYLANILINE
Ingred Name:EPOXY RESIN SYSTEM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN IRRITATION & POSSIBLE
ALLERGIC REACTIONS. PROLONGED & REPEATED CONTACT MAY CAUSE
SENSITIZATION WHICH WILL RESULT IN ALLERGIC REACTIONS.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:SKIN RASH,IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
First Aid:EYES/SKIN:FLUSH WITH PLENTY OF WATER.WASH SKIN THOROUGHLY
WITH SOAP & WATER,RUBBING ALCOHOL OR HAND CLEANER.DO NOT USE
SOLVENTS.REMOVE SOILED CLOTHING & WASH BEFORE REUSE.IF IRRITATION
PERSISTS,SEE DO CTOR.
* Fire Fighting Measures *
Flash Point Method:TOC
Extinguishing Media:DRY CHEMICAL OR HALON FIRE EXTING. / WATER
SPRAY,FOAM,OR FOG
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:DENSE SMOKE & TOXIC GASES MAY BE
LIBERATED.
* Accidental Release Measures *
GLASSES. COVER W/ABSORBENT MATERIAL - SCRAPE UP & TRANSFER TO METAL
CONTAINER. WIPE UP REMAINING RESIDUE W/SOLVENTS, OBSERVING SOLVENT
FLAMMABILITY CAUTIONS, O R USE DETERGENT.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:FOLLOW RECOMMENDED CURING SCHEDULE.; DUST INHALATION
FROM SANDING/GRINDING CURED ADHESIVE CAN LEAD TO EXPOSURE &
POSSIBLE HEALTH EFFECTS DUE TO IRRITATION FROM PARTICULATES.
* Physical/Chemical Properties *
HCC:B2
Boiling Pt:B.P. Text:DECOMPOSES
Vapor Density:NIL
Spec Gravity:>1.0
Evaporation Rate & Reference:NIL(N-BUTYL ACETATE = 1)
Solubility in Water:NIL
Appearance and Odor:VISCOUS GREY PASTE W/SLIGHT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS; STRONG LEWIS OR MINERAL ACIDS
Stability Condition to Avoid:SEE POLYMERIZATION SECTION
Hazardous Decomposition Products:CO, NO*X, ALDEHYDES,ACIDS &
UNDETERMINED ORGANICS
Conditions to Avoid Polymerization:AVOID MIXNG RESIN & CURNG AGT IN
GAS MAY RESULT.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF AS HAZARDOUS WASTE IAW APPROPRIATE
DOT HAZARD CLASS. IF NOT REGULATED BY DOT, DISPOSE OF AS ORM-E.
DISPOSAL METHOD CAN BE LAND BURIAL OR CHEMICAL INCINERATION AS BY
ALL GOVERNMENTAL AGENCIE S
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A RESP APPRVD BY NIOSH W/FILTER CARTRIDGES
APPRVD FOR DUST/FUMES/MISTS SHOULD BE WORN AT ALL TIMES DURING
THERMAL SPRAY PROCESS TO PROTECT OPERATOR FROM EXPOS TO DUST &
FUMES. RESPS MAY ALSO BE WORN W HEN PROD HANDLING GENERATES DUST.
Ventilation:PRODUCT SHOULD BE USED WITH THE APPROPRIATE LOCAL EXHAUST
VENTILATION PROVIDED.
Other Protective Equipment:EMER EYEWASH & DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . EAR PROT MUST BE WORN WHEN THE OPERATOR IS (ING
3)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
AVOID EXCESS SKIN CONT. EYE PROT: REC FOR PROCESS INDICATED.
* Product Identification *
* Composition/Information on Ingredients *
APPROPRIATE DURING OTHER PHASES OF PRODUCT HANDLING.
Ingred Name:OTHER PROT EQUIP: SUBJECTED TO EXCESS NOISE LEVELS (REFER
TO APPROP REGULATORY GUIDELINES). AN ALUMINIZED APRON (ING 4)
Ingred Name:ING 3: IS TO BE WORN DURING THE PLASMA SPRAY PROCESS. OTHER
APPROPRIATE PROTECTIVE CLOTHING MAY BE WORN AS (ING 5)
Ingred Name:ING 4: NECESSARY DURING PRODUCT HANDLING TO AVOID EXCESSIVE
CONTACT WITH THE SKIN.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION MAY CAUSE
PNEUMOCONIOSIS. INGESTION MAY CAUSE IRRITATION TO THE
GASTROINTESTINAL TRACT. PULMONARY, SKIN AND EYE IRRITANT DUE TO
ABRASIVE ACTION. UNDER NORMAL USE/CONDITIONS, ALUMINUM OXIDE MAY
BE FORMED. TARGET ORGANS: RESPIRATORY SYSTEM, GASTROINTESTINAL
TRACT, SKIN, EYES.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:EYES/SKIN: POSSIBLE IRRITATION. INHALATION:
POSSIBLE IRRITATION TO THE RESPIRATORY SYSTEM. INGESTION: POSSIBLE
IRRITATION TO THE GASTROINTESTINAL TRACT.
Medical Cond Aggravated by Exposure:CONSULT MD.
* First Aid Measures *
EYELID OPEN. IF IRRITATION PERSISTS, CONSULT MD. SKIN: WASH WITH
SOAP AND WATER. IF IRRITATION PERSISTS, CONSULT MD. INHALATION:
EXPOSE TO FRESH AIR. CONSULT MD IF IRRITATION OR RESPIRATORY
DISTRESS PERSISTS. INGESTION: CONSULT MD.
* Fire Fighting Measures *
Extinguishing Media:USE CLASS D FIRE EXTINGUISHER.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . TREAT AS A METALLIC FIRE.
Unusual Fire/Explosion Hazard:MODERATE FIRE HAZARD IN THE FORM OF WIRE
WHEN EXPOSED TO FLAME. ALUMINUM IS A FLAMMABLE SOLID; DO NOT EXPOSE
TO WATER OR MOISTURE.
* Accidental Release Measures *
Spill Release Procedures:DRY SWEEP LOOSE/SMALL PIECES OF WIRE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLES. STORE
PROD CONTRS IN WELL-VENTD, CLEAN, COOL & DRY AREA. STORE IN A
MANNER TO MINIMIZE PUNCTURES & BREAKAGE OF CONTRS.
Other Precautions:IN THE FORM OF A SOLID WIRE, THIS PRODUCT POSES LOW
TO NEGLIGIBLE HAZARDS IN TERMS OF INHALATION, INGESTION AND SKIN
CONTACT.
* Physical/Chemical Properties *
Spec Gravity:2.7 (H*2O=1)
Solubility in Water:NEGATIVE
Appearance and Odor:WIRE, NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALUMINUM IS INCOMPATIBLE WITH STRONG OXIDIZERS, ACIDS AND HALOGENATED
HYDROCARBONS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OZONE & NITRIC ACID ARE FORMED BY THE
PLASMA FLAME (SIMILAR TO WELDING FUMES). THIS ACTION IS INDEPENDENT
OF METAL WIRE.
* Disposal Considerations *
Waste Disposal Methods:EMPTY PRODUCT CONTIANERS, PRODUCT WASTE AND
CLEANING MEDIA SHOULD BE STORED AND DISPOSED OF ACCORDING TO THE
APPROPRIATE LOCAL, STATE AND FEDERAL REGULATORY GUIDELINES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NO SPECIAL REQMNTS UNDER ORDINARY
CONDITIONS/ADEQUATE VENT.
Ventilation:NO SPECIAL REQUIREMENTS W ADEQUATE VENT.
Other Protective Equipment:AS REQUIRED TO PREVENT PROLONGED CONTACT.
Supplemental Safety and Health
SYNONYMS:TITANIUM DI-ISOPROPYL-DI-ACETYLACETONE;TITANIUM
ACETYLACETONATE.OVEREXPOSURE:REPEATED CONTACT/INHALE OF PROPANOL
CAUSES CNS DEPRESS & NARCOSIS.
* Product Identification *
Product ID:TYZOR AA ORGANIC TITANATE
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of Overexposure:EYES:CAUSE SEVERE BURNS.SKIN:MODERATE
IRRITNT.SLIGHT ACUTE ORAL TOXICITY.SEE SUPPLEMENTAL DATA.
* First Aid Measures *
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE.
* Fire Fighting Measures *
Lower Limits:UNK
Upper Limits:UNK
Extinguishing Media:SM:H*2O ONLY;NO DRY CHEM. OR CO*2. LG:FLOOD
W.WATER.
Fire Fighting Procedures:SMALL AMOUNTS OF WATER MAY BE INEFFECTIVE.
Unusual Fire/Explosion Hazard:FLAMMABLE.KEEP AWAY FROM HEAT,SPARKS AND
FLAMES.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN OR SOAK UP WITH SAND OR EARTH.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED.MOISTURE
DEGRADES;KEEP DRY.STOREIN LOW FIRE RISK AREA.FREEZING AFFECTS
PHYSICAL CONDITION BUT WILL NOT DAMAGE.
Other Precautions:PREVENT BODILY CONTACT.WASH THOROUGHLY AFTER
HANDLING.NOT CORROSIVE TO STEEL,BUT PROMOTES RUSTING OF IRON
METALS.
* Physical/Chemical Properties *
HCC:F3
Vapor Density:UNK
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:DISPERSABLE
Appearance and Odor:CLEAR LIQUID,RED;SOUR RANCID UNPLEASANT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
SLOWLY HYDROLYZED BY WATER.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:FLAMMABLE ISOPROPYL ALCOHOL IS FORMED
BY HYDROLYSIS.
* Disposal Considerations *
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED.
Ventilation:USE SUFFICIENT VENTILATION.
Other Protective Equipment:NONE REQUIRED
Work Hygienic Practices:MFR GAVE NO INFORMATION OF MSDS.
Supplemental Safety and Health
NONE
* Product Identification *
Preparer's Name:G. LINDQUIST, CONSULTANT
CAGE:0E4P0
* Composition/Information on Ingredients *
Ingred Name:NAPHTHENIC HYDROTREATED MINERAL OIL
Ingred Name:LINSEED OIL
Other REC Limits:3.5 MG/CUM (NIOSH)
Ingred Name:MINERAL OIL
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:MANGANESE TALLATE DRIER
Fraction by Wt: 0-1%
OSHA PEL:1 MG MN/M3
ACGIH TLV:1 MG MN/M3
Ingred Name:ORGANIC PIGMENTS
Ingred Name:SYNTHETIC RESINS
Ingred Name:SOYA OIL
Ingred Name:REFINED MIDDLE DISTALLATE
Ingred Name:COBALT DRIER
Ingred Name:POLYMERIC WAX BLEND
Fraction by Wt: 1-3%
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:DIRECT CONTACT MAY CAUSE
IRRITATION. SKIN:PROLONGED CONTACT MAY CAUSE MINOR IRRITATION.
INHALATION:MAY CAUSE RESPIRATORY IRRITATION. INGESTION:MAY CAUSE
G/I IRRITATION.
Explanation of Carcinogenicity:MFR LISTED "CARCINOGEN: NO " BUT GAVE NO
OTHER COMMENTS ABOUT CARCINOGENICITY WERE RECORDED.
Effects of Overexposure:EYE, SKIN, RESPIRATORY OR G/I IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS W/DERMATITIS SHOULD AVOID
SKIN CONTACT.
* First Aid Measures *
First Aid:EYES:FLUSH W/WATER. SKIN:WASH W/SOAP & WATER. INGESTION:DO
NOT INDUCE VOMITING. CALL A PHYSICIAN. INHALATION:REMOVE INDIVIDUAL
TO FRESH AIR.
* Fire Fighting Measures *
Flash Point Method:CC
Autoignition Temp:Autoignition Temp Text:N/A.
Lower Limits:N/A.
Upper Limits:N/A.
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS
RECOMMENDED.
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:WIPE UP. DISPOSE OF WIPES IN APPROVED WASTE
CONTAINERS. IF PETROLEUM HYDROCARBON IS USED, PROVIDE SUFFICIENT
VENTILATION.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
*Handling and Storage *
Handling and Storage Precautions:AVOID STORAGE IN HOT AREAS. KEEP
CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions: REQUIRED.
* Physical/Chemical Properties *
HCC:N1
NRC/State Lic Num:
Melt/Freeze Pt:M.P/F.P Text:N/A.
Vapor Density:>1
pH:N/A.
Evaporation Rate & Reference:SLOWER THAN BU AC
Appearance and Odor:COLORED VISCOUS PASTE, OILY ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
YSTRONG OXICIZING AGENTS.
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS OF USE.
Hazardous Decomposition Products:MFR GAVE NO INFORMATION OF MSDS.
Conditions to Avoid Polymerization:MFR GAVE NO INFORMATION OF MSDS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED FOR NORMAL USE. USE NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GOOD VENTILATION IS REQUIRED. IN THE ABSENCE OF GOOD
VENTILATION, MECHANICAL DEVICES ARE RECOMMENDED.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS BEFORE EATING, DRINKING, OR SMOKING.
REMOVE CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
PH: 8.2-8.6. FIRST AID PROC: GIVING IPECAC/STICKING FINGER TO BACK OF
THROAT. CONT MD. NEVER GIVE ANYTHING BY MOUTH TO AN UNCON PERS.
SEEK MED ATTN.
* Product Identification *
CAGE:GRWCN
* Composition/Information on Ingredients *
Ingred Name:ETHANOL, 2-(2-ETHOXYETHOXY)-; (DIETHYLENE GLYCOL MONOETHYL
Fraction by Wt: 3%
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: CAN CAUSE IRRIT, CAUSING
CORNEAL DMG. SKIN: CAN CAUSE IRRIT & DEFAT. SKIN ABSORPTION: MAY
CAUSE HDCH, NAUS, DIZZ & VOMIT. INGEST: SINGLE DOSE INGEST ARE NOT
CONSIDERED HAZ. EXTREMELY LGE D OSES COULD CAUSE INJURY. CHRONIC:
EXTENDED OVEREXP CAN CAUSE DIZZ, HDCH, NAUS, & DRYING OF SKIN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:EXISTING DERMATOLOGICAL CONDITION
MAY BE AGGRAVATED BY OVEREXPOSURE.
* First Aid Measures *
WHILE KEEPING EYELIDS APART FOR MAX IRRIGATION. IF IRRIT PERSISTS,
CONT MD. SKIN: WASH OFF W/LGE AMTS OF SOAP & WATER. IF IRRIT
PERSISTS, C ONT MD. WASH CONTAM CLTHG BEFORE REUSE.INHAL: IF VICTIM
COMPLAINS OF HDCH, DIZZ/NAUS, REMOVE VICTIM TO FRESH AIR. IF BRTHG
BECOMES DFCLT/CNDTN PERSISTS, CONT MD. INGEST: INDUCE VOMIT BY (SUP
DAT)
* Fire Fighting Measures *
Flash Point Method:SCC
Flash Point:NONE
Lower Limits:1.2%
Extinguishing Media:FOAM, CARBON DIOXIDE, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . IF INVOLVED IN A FIRE, SPRAY CONTAINERS WITH WATER TO
KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:AREA WILL BECOME SLIPPERY IF MATERIAL IS
RELEASED.
* Accidental Release Measures *
Spill Release Procedures:DIKE AREA TO CONTAIN MATERIAL. AREA MAY BECOME
SLIPPERY. ABSORB PRODUCT ONTO POROUS MATERIAL SUCH AS SAND,
DIATOMACEOUS EARTH OR COMMERCIAL ABSORBENT MATERIAL. SHOVEL UP INTO
LEAK-PROOF CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT STORE NEAR ACIDS, OXIDIZERS,
AND ALKALIES. KEEP FROM EXCESSIVE HEAT AND KEEP FROM FREEZING. DO
NOT STORE NEAR CONSUMABLES.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. READ AND FOLLOW ALL
DIRECTIONS. USE IN A MANNER CONSISTENT WITH PRODUCT INTENT.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
pH:SUPDAT
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:COMPLETELY
Appearance and Odor:WHITE OPAQUE LIQUID WITH MILD ACRYLIC ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS, STRONG ALKALIES AND OXIDANTS.
Stability Condition to Avoid:EXTREME HEAT OR FREEZING TEMPERATURES.
Hazardous Decomposition Products:NORMAL PRODUCTS OF COMBUSTION: CARBON
DIOXIDE AND CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:CONSULT LOCAL, STATE OR FEDERAL AUTHORITIES FOR
PROPER DISPOSAL.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED < APPLIC LIM
BY VENT, WEAR PROPERLY FITTED ORG VAP/PARTICULATE RESP APPRVD BY
NIOSH/MSHA FOR PROT. WHEN SANDING, WIREBRUSHING, ABRADING,
BURNING/WELDING DRIED FILM, WEAR NIOSH/MSHA APPRVD PARTICULATE
RESP.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
EXTING MEDIA: CLSD CONTRS TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO
WHEN EXPOSED TO EXTREME HEAT. EXPLO HAZ: SURF REQUIRES SPEC PREC.
DURING EMER CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ.
SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED ATTN. EFTS OF OVEREXP:
OVEREXP TO SOLV W/PERM BRAIN & NERV SYS DMG.
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 5%
ACGIH TLV:ASPHYXIANT
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
Fraction by Wt: <5%
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Fraction by Wt: <5%
Ingred Name:WASTE DISP METH: INCINERATE. DEPRESSURIZE CONTAINER.
DISPOSE OF I/A/W FEDERAL, STATE & LOCAL REGS REFARDING POLLUTION.
Ingred Name:OTHER PREC: PILOT LIGHTS & HEATERS. TURN OFF STOVES, ELEC
TOOLS & APPLIANCES & ANY OTHER SOURCES OF IGNIT. (ING 8)
Ingred Name:ING 7: CONSULT NFPA CODE. USE APPRVD BONDING & GROUNDING
PROC. CONTENTS UNDER PRESS. DO NOT PUNCTURE, INCIN/ (ING 9)
RADIATORS, STOVES, HOT WATER & OTHER HEAT SOURCES COULD CAUSE (ING
Ingred Name:ING 9: CONTAINER TO BURST. DO NOT TAKE INTERNALLY. KEEP OUT
CONTENTS MAY BE HARMFUL OR FATAL.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TO MIN EXPOS, FOLLOW REC FOR PROPER
USE, VENT & PERS PROT EQUIP. ACUTE: IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERV SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
POSS DEATH. HDCH, DIZZ, NAUS & L OSS OF COORD INDICATE EXCESS EXPOS
TO VAPS/SPRAY MISTS. REDNESS & ITCH/BURNING SENSATION MAY INDICATE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: EYE/EXCESS SKIN EXPOS. CHRONIC: PRLNG
EXPOS TO SOLV MAY CAUSE ADVERSE EFTS TO LIVER, URINARY, BLOOD
FORMING, CARDIO-VASCULAR & REPRO SYS. RATS EXPOSED TO TITANIUM
EXPOS LEVELS ARE NOT ATTAINABLE IN WORKPLACE. RPTS HAVE ASSOC RPTD
& PRLNG (SUP DAT)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:INHAL: IF ANY BRTHG PROBLEMS OCCUR DURING USE, LEAVE AREA &
GET FRESH AIR. IF PROBLEMS REMAIN/OCCUR LATER, IMMED GET MED ATTN.
SKIN: WASH AFFECTED AREA THORO W/SOAP & WATER. REMOVE CONTAM CLTHG
& LAUN DER BEFORE REUSE. EYES: FLUSH W/LGE AMTS OF WATER FOR AT
* Fire Fighting Measures *
Lower Limits:0.5%
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZ ARE
PREF. WATER MAY BE USED TO COOL (SUP DAT)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS & OPEN FLAME. CLSD CONTRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT (SUP DAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:THIS COATING MAY CONTAIN MATLS
CLASSIFIED AS NUISANCE PARTICULATES WHICH MAY BE PRESENT AT HAZ
LEVELS ONLY DURING SANDING/ABRADING OF DRIED FILM.
Other Precautions:USE ONLY W/ADEQ VENT. AVOID BRTHG VAP/SPRAY MIST.
AVOID CONT W/SKIN & EYES. CONTENTS EXTREMELY FLAM. KEEP AWAY FROM
HEAT, SPARKS & OPEN FLAME. DURING USE & UNTIL ALL VAPS ARE GONE,
KEEP AREA VENT. DONOT SMOKE. EXTING ALL FLAMES, (ING 7)
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENTS SECTION.
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
APPLIC EPA HAZ WASTE #. WASTE FROM PRODS CONTAINING METHYL ETHYL
KETONE MAY ALSO RE QUIRE TESTING FOR EXTRACTABILITY. DO NOT (ING 6)
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:FOR BRIEF CONTACT,NO PRECAUTIONS OTHER THAN
CLEAN BODY-COVERING CLOTHING.
Work Hygienic Practices:N/K
Supplemental Safety and Health
ML/KG.ROUTES OF ENTRY:INHAL/SKIN/INGEST .EFTS OF OVEREXPOS:RPTD
EXCESS EXPOS-MINOR LUNG,LIVER,KIDNEY EFTS;ANESTHETIC/NARCOTIC EFTS
.
* Product Identification *
Product ID:DOWANOL(R) PM GLYCOL ETHER
* Composition/Information on Ingredients *
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER
Other REC Limits:N/K
Ingred Name:2-METHOXY-1-PROPANOL
Fraction by Wt: 3%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:SLIGHT TRANSIENT IRRIT.CORNEAL INJURY
UNLIKELY.SKIN:PRLNG/RPTD EXPOS-IRRIT.PRLNG CONTACT W/ LRG
AMTS-DROW.INGEST:SINGLE DOSE TOX LOW.AMTS LARGER THAN AMTS
INCIDENTAL TO HANDLING MAY CAUSE INJURY. INHAL:ODOR OBJECTIONABLE
PPM;ANESTHETIC EFTS SEEN.(SUP DA)
Medical Cond Aggravated by Exposure:N/K
* First Aid Measures *
OFF IN FLOWING WATER/SHOWER.INGEST:INDUCE VOMIT IF LARGE AMTS
INGESTED.CONSULT MD.INHAL:REMOVE TO FRESH AIR.IF NOT BREATHING,GIVE
MOUTH-TO-MO UTH RESUSCITATION.IF BREATHING IS DIFFICULT,GIVE
OXYGEN.CALL MD.MD NOTE:NO SPECIFIC ANTIDOTE.SUPPORTIVE
CARE.TREATMENT BASED ON JUDGMENT OF PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:WATER FOG,ALCOHOL RESISTANT FOAM,CO*2,DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT (POSITIVE PRESSURE).
Unusual Fire/Explosion Hazard:KEEP VAPORS AWAY FROM POSSIBLE IGNITION
SOURCES.
* Accidental Release Measures *
Spill Release Procedures:SOAK UP W/ SUITABLE,NON-REACTIVE ABSORBENT
MATERIAL.COLLECT W/ RUBBER SHOVEL INTO CONTAINERS FOR DISPOSAL.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:GROUND ALL EQUIPMENT.HANDLE WITH
REASONABLE CARE.AVOID BREATHING VAPORS.
Other Precautions:A DELAYED HEALTH HAZARD.A FIRE HAZARD.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:SUPP DATA
Evaporation Rate & Reference:N/K
Solubility in Water:INFINITELY
Appearance and Odor:CLEAR,COLORLESS LIQUID.INFORMATION NOT AVAILABLE ON
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL
Stability Condition to Avoid:STABLE UNDER NORMAL STORAGE CONDITIONS.
Hazardous Decomposition Products:NONE KNOWN
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .BURN IN APPROVED INCINERATOR.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE REQUIRED WHEN USED WITH ADEQUATE
VENTILATION.
Ventilation:PROVIDE SUFFICIENT MECHANICAL GENERAL AND/OR LOCAL EXHAUST
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER WHICH
MEET ANSI DESIGN CRITERIA . REMOVE AND WASH CONTAMINATED CLOTHING.
Work Hygienic Practices:WASH HANDS BEFORE EATING AND DO NOT SMOKE WHILE
USING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Preparer's Name:JEFF ZYCH
* Composition/Information on Ingredients *
Ingred Name:ETHANOL, 2-(DIETHYLAMINO)-; (DIETHYLAMINOPHENOL)
Fraction by Wt: 5%
ACGIH TLV:S, 2 PPM
Ingred Name:ETHANOL, 2-PHENOXY-; (ETHYLENE GLYCOL MONOPHENYL ETHER)
Fraction by Wt: <5.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:9-OCTADECANOIC ACID, (Z)-; (OLEIC ACID)
Fraction by Wt: 5%
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: <5.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MATERIAL VOLATILE ORGANIC COMPOUND:NOT APPLICABLE.
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYE CONTACT:PROLONGED OR FREQUENT
SKIN CONTACT MAY CAUSE DEFATTING, DRYNESS WITH IRRITATION
ESPECIALLY IF DERMATITIS ALREADY EXISTS. EYE CONTACT CAN CAUSE
IRRITATION. SKIN ABSORPTION:MAY CAUSE DE RMATITIS AND IRRITATION.
INGESTION:MAY CAUSE HEADACHE, DIZZINESS, NAUSEA AND
UNCONSCIOUSNESS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE REPORTED.
* First Aid Measures *
INHALATION:REMOVE VICTIM FROM EXPOSURE. INGESTION:DO NOT INDUCE
VOMITING. DRINK THREE GLAS SES OF WATER TO DILUTE AND GET MEDICAL
ATTENTION IMMEDIATELY.
* Fire Fighting Measures *
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:ABSORB SPILL WITH ABSORBENT MATERIAL SUCH AS
VERMICULITE OR SAND.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. STORE ONLY
IN ORIGINAL CONTAINERS.
Other Precautions:
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Spec Gravity:1.0 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:DISPERSIBLE
Appearance and Odor:VISCOUS LIQUID WITH BLAND ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN OUTDOOR/OPEN AREAS W/UNRESTRICTED
VENTILATION, USE NIOSH APPROVED MECHANICAL FILTER RESPIRATOR TO
REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY DURING SPRAY
APPLICATION. IN RESTRICTED VENTILATION AR EAS, USE NIOSH APPROVED
MECHANICAL FILTER RESPIRATORS DESIGNED TO REMOVE PARTICULATES. IN
CONFINED AREAS, USE NIOSH APPROVED AIR-LINE RESPS & HOODS.
Ventilation:PROVIDE GENERAL DILUTION/LOCAL EXHAUST VENTILATION KEEP
REMOVE DECOMPOSITION PRODUCTS DURING WELDING & FLAME CUTTING ON
SURFACES COATED W/THIS PRODUCT.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . AS NEEDED, USE BODY PROTECTION, SUCH AS RUBBER
APRON, ETC.
Work Hygienic Practices:BEFORE SMOKING OR EATING, WASH HANDS
THOROUGHLY.
Supplemental Safety and Health
OTHER PREC: REQUIRED LEVEL, OR USE NIOSH APPROVED MECHANICAL FILTER
RESPIRATORS FOR PROTECTION.
* Product Identification *
* Composition/Information on Ingredients *
= Wt:2.
Other REC Limits:N/K
OSHA STEL:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF SOLVENT VAPOR MAY
CAUSE NOSE, THROAT AND LUNG IRRITATION. DIRECT EYE CONTACT MAY
CAUSE MODERATE TO SEVERE IRRITATION. MAY CAUSE AN ALLERGIC SKIN OR
RESPIRATORY REACTION IN PEOPLE WHO ARE SENSITIVE (ALLERGIC) TO
ACRYLIC POLYMERS. REPEATED OR PROLONGED OVEREXPOSURE MAY CAUSE
LIVER, KIDNEY AND CENTRAL NERVOUS SYSTEM DAMAGE. POSSIBLE BIRTH
DEFECT HAZARD. CONTAINS ETHYLENE GLYCOL W HICH MAY CAUSE BIRTH
DEFECTS BASED ON ANIMAL DATA.
Effects of Overexposure:SEE HEALTH HAZARDS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH IMMEDIATELY WITH
FOR MEDICAL TREATMENT. SKIN: WASH AFFECTED AREA WITH LARGE AMOUNTS
OF WA TER. REMOVE CONTAMINATED CLOTHING. INGESTION: CALL A
PHYSICIAN IMMEDIATELY .
* Fire Fighting Measures *
Lower Limits:0.7%
Upper Limits:1.0%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLOSED. ISOLATE FROM
HEAT, SPARKS, ELECTRICAL EQUIP, & OPEN FLAME. CLOSED CONTRS MAY
EXPLODE WHEN EXPOSED TO EXTREME HEAT. IN THE ABSENCE OF
ELECTRICITY, A WATER SPRAY (FOG NOZZLE IS PREFERRED) MAY BE USED
TO COOL CONTRS. AVOID EXPOS TO DECOMP. FLAMMABILITY CLASSIFICATION:
OSHA: N/A.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES, AND ELECTRICAL, STATIC OR FRICTION SPARKS). AVOID
BREATHING VAPORS, AND VENTILATE AREA. REMOVE WITH INERT ABSORBENT
SUCH AS SAND, KITTY LITTER, ET C, AND USE NON-SPARKING TOOLS.
*Handling and Storage *
Handling and Storage Precautions:SECURE CLOSURES & KEEP CONTRS UPRIGHT
TO PVNT LEAKAGE. STORE LGE QTYS ONLY IN BLDGS DESIGNED TO COMPLY
DO NOT GET IN EYES/ON SKIN. AVO ID BRTHG VAPS/SPRAY MIST. DO NOT
STORE/USE NEAR HEAT.
Other Precautions:DO NOT FLAME CUT, BRAZE/WELD W/OUT NIOSH APPRVD MECH
FILTER RESP/APPROP & ADEQ VENT. ALL ELEC EQUIP & INSTALLATIONS
SHOULD BE MADE & GROUNDED I/A/W NATL ELEC CODE. IF WORKMEN ARE
EXPOSED TO SPRAY APPL ICATION/ABRASIVE BLAST CLEANING, ENGINEERING
& ADMIN CTLS MUST BE USED TO MAINTAIN EXPOS LEVEL BELOW OSHA (SUP
DAT)
* Physical/Chemical Properties *
Vapor Pres:SEE INGREDIENT 1
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING. FUMES MAY PRODUCE CARBON
DIOXIDE AND CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A SAFE MANNER IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS THAT APPLY TO INCINERATION OR
SECURE LANDFILL.
* MSDS Transport Information *
Transport Information:DOT FLAMMABILITY CLASSIFICATION: NOT APPLICABLE.
* Regulatory Information *
SARA Title III Information:ETHYLENE GLYCOL IS A CHEMICAL SUBJECT TO THE
State Regulatory Information:
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED IF USED AS INTENDED
Ventilation:NONE REQUIRED IF USED AS INTENDED
Other Protective Equipment:NONE REQUIRED IF USED AS INTENDED
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
THE MANUFACTURER STATES THIS DEVICE IS A MANUFACTURED ARTICLE IN
* Product Identification *
Preparer's Name:FRANK E. TROJAN
* Composition/Information on Ingredients *
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE AND CHRONIC- PRODUCT IS AN
ARTICLE. IT IS A RECEIVER PROTECTOR TUBE WHICH CONTAINS A SMALL
AMOUNT OF TRITIUM. THE TUBE IS SEALED AND NORMAL HANDLING WILL
PRESENT NO RADIATION PROBLEMS. SIGNIFICA NT EXPOSURE TO A
RADIONUCLIDE MAY CAUSECANCER.
Explanation of Carcinogenicity:CAUTION! CONTAINS RADIOACTIVE MATERIAL.
MAY CAUSE CANCER.
Effects of Overexposure:NONE IN NORMAL HANDLING CONDITION.
Medical Cond Aggravated by Exposure:HEALING OF DAMAGED TISSUES MAY BE
PROLONGED.
* First Aid Measures *
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH
ORAL:IF CONSCIOUS, DRINK PLENTY OF WATER OR FLUID. GET MEDICAL
ATTENTION.IF EXPOSURE IS SUSPECTED, URINE ASSAY FOR TRITIUM
SHOULD BE PERFORMED.
* Fire Fighting Measures *
Flash Point:NOT RELEVANT
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NOT RELEVANT
* Accidental Release Measures *
Spill Release Procedures:IF BROKEN, WEAR PROTECTIVE EQUIPMENT. COLLECT
AND TRANSFER TO PROPER CONTAINER FOR DISPOSAL.
Neutralizing Agent:NOT RELEVANT
*Handling and Storage *
Handling and Storage Precautions:HANDLE WITH CARE.
Other Precautions:WASH HANDS BEFORE EATING OR DRINKING. EXPOSURE
* Physical/Chemical Properties *
HCC:A2
NRC/State Lic Num:NOT RELEVANT
Decomp Temp:Decomp Text:NOT KNOWN
Spec Gravity:NOT RELEVANT
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:NOT RELEVANT
Appearance and Odor:THIS DEVICE IS AN ARTICLE (ELECTRON TUBE)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS
Stability Condition to Avoid:EXCESSIVE HEAT (TEMPERATURES IN EXCESS OF
Hazardous Decomposition Products:UNBOUND TRITIUM
* Disposal Considerations *
Waste Disposal Methods:NOT RELEVANT
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:SPRAY BOOTHS
Other Protective Equipment:RESPIRATORS WHILE SPRAYING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ZINC (SARA III)
Ingred Name:AQUEOUS ALKALI SILICATE
Ingred Name:CHROMIUM (SARA III)
Fraction by Wt: <0.3%
OSHA PEL:1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:EYE/SKIN: ALKALI BURNS. INHALATION OR ATOMIZED
MATERIAL WILL PRODUCE IRRIT OF LUNGS & MUCOUS MEMBRAN
* First Aid Measures *
WITH WATER,OBTAIN MED ATTN. INGESTION:GIVE LARGE AMOUNT OF
WATER,OBTAIN MED ATTN. INHALATION: OBTAIN MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE,SAND
Fire Fighting Procedures:DO NOT USE WATER BASED EXTINGUISHING AGENTS.
Unusual Fire/Explosion Hazard:DIRECT CONTACT WITH ALKALIS OR ACIDS MAY
PRODUCE HYDROGEN GAS.
* Accidental Release Measures *
Spill Release Procedures:FLUSH SPILLAGE WITH EXCESS WATER IMMEDIATELY.
*Handling and Storage *
FREEZE.
* Physical/Chemical Properties *
Vapor Density:0.7
Spec Gravity:2.6
Evaporation Rate & Reference:1 (WATER)
Solubility in Water:MISCIBLE
Appearance and Odor:ODORLESS,GRAY GREEN COLOR WHEN MIXED.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS,ALKALIS,OXIDIZERS
Hazardous Decomposition Products:REACTIONS W/ACIDS & OTHER MATERIALS
MAY PRODUCE HYDROGEN GAS
* Disposal Considerations *
Waste Disposal Methods:REMOVE PIGMENT BY FILTERATION,DISCARD AS SOLID
WASTE. LIQUID PORTION SHOULD BE TREATED W/SODIUM METABISULFITE
AFTER ACIDIFICATION TO PH 2-4. AFTER CHROMIUM IS REDUCED,ADJUST PH
WITH ALKALI TO PH 7.0. COMPLY WITH ALL NEW ENVIRONMENTAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE ORGANIC VAPOR CARTRIDGE, &/OR ACID GASES
CONFINED AREA, USE AIR-FED HOOD.
Ventilation:USE LOCAL EXHAUST WHEN APPLYING MATERIAL IN CONFINED AREAS.
KEEP VAPOR BELOW TLV.
Other Protective Equipment:USE PROTECTIVE CLOTHING AND CHANGE
CONTAMINATED CLOTHING IMMEDIATELY. PROVIDE EMERGENCY SHOWERS &
EYEWASH FOUNTAINS.
Work Hygienic Practices:TRAIN EMPLOYEES ON ALL SPECIAL HANDLING
PROCEDURES IN THIS SECTION BEFORE THEY WORK WITH THIS PRODUCT.
Supplemental Safety and Health
REPORTS HAVE SHOWN THAT ASSOCIATED REPEATED AND PROLONGED OCCUPATIONAL
OVEREXPOSURE TO SOLVENTS CAN CAUSE PERMANENT BRAIN AND NERVOUS
SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING THE CONTENTS MAY BE HARMFUL ORFATAL. USE ONLY WITH
ADEQUATE VENTILATION.
* Product Identification *
Kit Part:Y
Preparer's Name:E. SOETERIK
* Composition/Information on Ingredients *
Ingred Name:EPOXY RESIN
Other REC Limits:NONE RECOMMENDED
Ingred Name:RHEOLOGICAL ADDITIVES
Other REC Limits:NONE RECOMMENDED
Ingred Name:NAPHTHA, LIGHT AROMATIC
Other REC Limits:NONE RECOMMENDED
Ingred Name:MAGNESIUM SILICATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICONE DIOXIDE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: NAUSEA, DIZZINESS, HEADACHE AND
CONVULSIONS. CHRONIC: POSSIBLE SKIN SENSITIZATION.
Explanation of Carcinogenicity:THIS PRODUCTS INGREDIENTS ARE NOT FOUND
IN NTP, IARC OR OSHA'S LIST.
Effects of Overexposure:INHALED-COUGHING, SHORTNESS OF BREATH, MAY
CAUSE DIZZINESS. CONTACT WITH SKIN OR EYES-BURNING SENSATION, RASH
BREAKOUT WITH SKIN TURNING PINK AND REDNESS OF EYES. ABSORBED
THROUGH SKIN-SKIN RASH MAY C AUSE BURNING OF SKIN INFLAMMATION.
SWALLOWED-VOMITING DUE TO UNPLESANT TASTE. MAY CAUSE DIARRHEA OR
STOMACH CRAMPS.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA AND OTHER
RESPIRATORY DISEASE.
* First Aid Measures *
First Aid:EYE-FLUSH IMMEDIATELY WITH FRESH WATER BY AN EYE WASH
APPARATUS OR BY HAND. SEEK MEDICAL ATTENTION. SKIN-WASH IMMEDIATELY
WITH WATER. THEN WASH WITH SOAP & WATER, RINSE IMMEDIATELY. SEEK
MEDICAL ATTEN TION.INHALED-MOVE PERSON TO FRESH AIR; ARTIFICIAL
RESPIRATION IF NECESSARY. SEEK MEDICAL ATTENTION. SWALLOWED-SEEK
MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:SCC
Autoignition Temp:Autoignition Temp Text:UNKNON
Lower Limits:1.4
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:BLANKET FLAME WITH ONE OF THE ABOVE. DO NOT
ENTER FIRE AREA WITHOUT PROPER PROTECTION & EQUIPMENT INCLUDING
NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:KEEP MATERIAL AWAY FROM HEAT, SPARKS &
OPEN FLAMES. EXPLOSIVE WHEN HEATED. STAY A SAFE DISTANCE FROM FIRE
WHEN EXTINGUISHING.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL TYPES OF IGNITION. PROVIDE
PROTECTION SECTION).
*Handling and Storage *
Handling and Storage Precautions:KEEP IN DRY AREA AT ROOM TEMPERATURE,
COSEQUENTLY, SPILLAGE.
Other Precautions:WASH CONTAMINATED EQUIPMENT WITH FRESH WATER.
***RECOMMENDATIONS TO PHYSICIANS: CONSULT WITH THE POISON CONTROL
CENTER. FOR WORKERS WHO ARE EXPOSED REGULARLY, PROVIDE DETAILED
PERIODIC EXAMINATIONS.** *
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:4.8
Vapor Density:2.1
Spec Gravity:1.3
Solubility in Water:POOR
Appearance and Odor:TYPICAL PAINT APPERANCE WITH STRONG SOLVENT ODOR
TYPICAL OF BUTANOL.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WHEN "A" AND "B" ARE MIXED, KEEP AWAY FROM HEAT. HEAT WILL CREATE A
RAPID CHEMICAL REACTION. EMITS HEAT.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAMES. DO NOT ALLOW
VAPOR TO ACCUMULATE.
Hazardous Decomposition Products:COMBUSTIBLE FUMES MAY ACCUMULATE IN
CONFINED AREA & SPARKS OR OPEN FLAMES MAY IGNITE IT
Conditions to Avoid Polymerization:HEAT, SPARKS AND OPEN FLAMES WHEN A
& B ARE MIXED.
* Disposal Considerations *
Waste Disposal Methods:USE ANY KIND OF ABSORBENT TO ABSORB SPILLED
MATERIAL AND PUT IN A METAL CONTAINER MARKED "DO NOT USE THIS
MATERIAL". DISPOSE OF LEGALLY. DISPOSE OF ALL WASTE IN ACCORDANCE
WITH FEDERAL, STATE AND LOCA L REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO ENTRAIN ALL PARTICULATE
EMISSIONS. HEPA FILTER REQUIRED. NO LEAKS ON PRESSURE SIDE OF FAN.
Other Protective Equipment:USE COVERALLS OR DISPOSABLE CLOTHING.
Work Hygienic Practices:WET WORK TO THE DEGREE POSSIBLE. WASH HANDS
AFTER HANDLING GASKET. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
MSDS GENERATED BY HMIS TECHNICIAN. MANUFACTURER IS UNKNOWN OR OUT OF
BUSINESS.
* Product Identification *
Preparer's Name:HMIS TECHNICIAN
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
Ingred Name:RUBBER
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:MINOR EYS/SKIN IRRITATION.
INGESTION- IRRITATION OF GI TRACT. INHALATION-IRRITATION OF
RESPIRATORY TRACT. CHRONIC: ASBESTOSIS, LUNG CANCER, &
MESOTHELIOMA, ALL OF WHICH ARE DISABLING AND FATAL D ISEASES OF THE
LUNG. INHALATION AND INGESTION OF ASBESTOS FIBERS MAY CAUSE CANCER
OF THE BOWEL.
Explanation of Carcinogenicity:ASBESTOS IS A KNOWN HUMAN CARCINOGEN.
Effects of Overexposure:INHALATION: FATIGUE AND SHORTNESS OF BREATH
THAT GETS WORSE WITH TIME AND EVENTUALLY BECOMES DISABLING. EYES:
IRRITATION. SKIN: IRRITATION. INGESTION: MILD STOMACH DISTRESS.
DIARRHEA, VOMITING, AND NA USEA.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND TUBERCULOSIS
ARE ALL GENERALLY AGGRAVATED BY EXPOSURE TO ASBESTOS FIBERS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. SEE DOCTOR. EYES: RINSE
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, SEE DOCTOR.
INGESTION: DIL UTE WITH WATER. DO NOT INDUCE VOMITING.SEE DOCTOR.
* Fire Fighting Measures *
Flash Point:NOT REQUIRED
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
* Accidental Release Measures *
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE-ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTAN T AND THEN SHOVEL OR MOP UP
CONTAMINATION.
*Handling and Storage *
Handling and Storage Precautions:GASKET IS NONFRIABLE & WILL NOT SHED
FIBERS IN NORMAL USE AND STORAGE. USED GASKETS SHALL BE WETTED
BEFORE, DURING & AFTER DISASSEMBLY FROM AN ENGINE.
Other Precautions:IF IT IS NECESSARY TO CUT OR IMPACT THE GASKET WHILE
INSTALLING IT, WEAR A RESPIRATOR AND PROTECTIVE CLOTHING. USED
GASKETS SHALL BE IDENTIFIED AND DISPOSED OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDERAL REGULATIONS.
* Physical/Chemical Properties *
HCC:T6
Solubility in Water:INSOLUBLE
Appearance and Odor:GASKET MADE OF ASBESTOS AND RUBBER
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, AND STRONG ALKALIS
Stability Condition to Avoid:ACCUMULATIONS OF DUST
Hazardous Decomposition Products:ASBESTOS DUST
* Disposal Considerations *
Waste Disposal Methods:WET THE MATERIAL WITH WATER AND SURFACTANT.
PLACE IN 6 MIL THICK POLYETHYLENE PLASTIC BAG. PLACE THESE BAGS
INTO ANOTHER POLY BAG OR A SAFE PLACE UNTIL IT CAN BE SHIPPED TO AN
APPROVED DISPOSAL SITE. IDENTIFY WITH ASBESTOS CANCER WARNING
LABEL.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH CERTIFIED EQUIPMENT LIST (PUBLICATION NO.
Ventilation:MECHANICAL
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM BISULFITE (SASA III)
OSHA PEL:5 MG/M3
* Hazards Identification *
Effects of Overexposure:SKIN CONTACT/CHEMICAL BURNS. EYE
CONTACT/CHEMICAL BURNS.
* First Aid Measures *
First Aid:SKIN CONTACT: WASH WITH SOAP AND WATER. EYE CONTACT: FLUSH
WITH WATER. SEEK MEDICAL ATTENTION.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY PLACE.
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:C1
Solubility in Water:APPRECIABLE
Appearance and Odor:CREAM COLORED POWDER, MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MATERIALS WHICH REACT VIOLENTLY WITH ACIDS.
Hazardous Decomposition Products:SOX
* Disposal Considerations *
Waste Disposal Methods:NEUTRALIZE ACID WITH AND RELEASE TO SEWER.
COMPLY WITH ALL FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPRVD GAS & VAP RESP, OR POWER
AIR PURIFYING, WHEN VENT DOES NOT KEEP FUME EXPOS BELOW ALLOWABLE
LIMITS. WHEN ENGINEERING/ADMIN CTLS ARE NOT FEASIBLE TO CTL OVEREXP
OR WHILE THEY ARE B EING INSTITUTED, NIOSH/MSHA APPRVD RESP.
Ventilation:IF NATURAL VENT IS DEEMED INSUFFICIENT, LOC EXHST VENT SHLD
BE USED TO KEEP WORKER EXPOSURES WITHIN ALLOWABLE(SUPP DATA)
Other Protective Equipment:ALWAYS WEAR FULL BODY, FLAME & HEAT
RESISTANT CLOTHING, HEAD PROTECTION AND LEATHER/FLAME RESISTANT
BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
DECOMP PROD:CNTN INGREDS ORIGINATING FROM THE OXIDATION & RXN OF THE
MATL BEING CUT. CARCIN COMMENTS: ANTICIPATED TO BE CARCIN.
LIMITS DURING OPERATION.
* Product Identification *
Product ID:CUTTING RODS
CAGE:0SAH3
CAGE:0SAH3
* Composition/Information on Ingredients *
WILL CAUSE SEVERE BURNS.
Ingred Name:IRON
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Fraction by Wt: SEE ING
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICON
Fraction by Wt: 1.8-4%
Ingred Name:MANGANESE (SARA III)
Fraction by Wt: < 1.2%
OSHA PEL:5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST
Fraction by Wt: SEE ING
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Fraction by Wt: SEE ING
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Fraction by Wt: SEE ING
Ingred Name:SULFUR
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHOSPHOROUS (WHITE); (PHOSPHOROUS)(SARA III)
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Fraction by Wt: SEE ING
Ingred Name:EFTS OF OVEREXP: PARTICLES MAY ALSO IGNITE COMBUSTIBLES IN
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EXPOS BY INHAL OF FUMES FROM BURNING
OR WELDING, DUSTS FROM GRINDING OR CUTTING. ACUTE:EXCESSIVE INHAL
OF FUMES FROM MANY METALS CAN PRODUCE AN ACUTE RXN KNOWN AS (METAL
FUME FEVER). VERY SIMILAR & EA SILY CONFUSED W/FLU SYMPS.
CHRONIC:CHRONIC INHAL OF FUMES MAY LEAD TO SIDEROSIS & REDUCE PULM
FUNCTION.(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL:IARC MONOGRAPHS SUPPLEMENT, VOL
(SUPP DATA)
Effects of Overexposure:HLTH HAZ: OTHER HAZ: THE MOST OBVIOUS & IMMED
HAZ COMES FROM THE INTENSE BURNING ACTION OF LISTED PRODS UNDER
NORMAL USE & CNDTNS. AIRBORNE MOLTEN PARTICLES PROPELLED BY O*2
PRESSURE CAN BURN THE PERS ON(S) USING THESE EQUIPMENTS OR IN THE
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: REMOVE VICTIM FROM ADVERSE ENVIRONMENT. ADMIN OXYGEN
IF BRTHG, ARTF RESP IF NOT BRTHG. TREAT SKIN AREA EXPOSED TO BURNS.
ALWAYS SEND FOR MED AID IMMED FOR ANY INDUST ACCIDENT. SKIN: FLUSH
W/COP IOUS AMTS OF WATER. CALL MD . EYE: IMMED FLUSH W/POTABLE
GET MD IMMEDIATELY .
* Fire Fighting Measures *
Extinguishing Media:EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:METAL PRODUCTS ARE NOT FIRE HAZ. DUST GEN
BY CUTTING/GRINDING MAY PRESENT FIRE OR EXPLOSION HAZARD.
* Accidental Release Measures *
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:METAL ITSELF DOES NOT PRESENT HLTH HAZ
UNLESS IT IS WELDED, BURNED, GROUND/CUT. DURING THESE PROC, IT IS
POSS THAT EXCESS FUME/DUST MAY BE GENERATED.
Other Precautions:IT IS ADVISED THAT YOUR PARTICULAR OPERATION BE
EVALUATED BY A COMPETENT HEALTH PROFESSIONAL TO DETERMINE WHETHER A
HAZARD EXISTS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:CONTAM DURING STORAGE/HNDLG, W/GREASE,
OILS, OR CHEMICALS THAT COULD REACT WITH OXYGEN, DURING NORMAL
OPERATION.
Hazardous Decomposition Products:METAL FUME CNTNG MATLS LISTED IN
GENERIC INGREDS SECT. NOTE: DURING NORMAL OPERATION FUMES EMITTED
WILL ALSO (SUPP DATA)
* Disposal Considerations *
Waste Disposal Methods:AWAYS DISCARD ANY PRODUCTS, RESIDUES, OR
BI-PRODUCT ACCUMULATION IN AN ENVIRONMENTALLY ACCEPTABLE MANNER; IN
FULL COMPLIANCE WITH ALL LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DDTC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
* Product Identification *
Preparer's Name:DOD HMIS/DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
OSHA PEL:0.2 FIBERS/CC
Ingred Name:ASBESTOS & SYNTHETIC RESIN & NICKEL ALLOY COMPOSTION
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
*Handling and Storage *
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
* Physical/Chemical Properties *
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NO SPECIAL CONTROL MEASURES NECESSARY UNDER
NORMAL CONDITIONS OF USE. USE NIOSH APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NO SPECIAL CONTROL MEASURES NECESSARY UNDER NORMAL
CONDITIONS OF USE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN ABSORPTION: NOT TOXIC
(EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HEALTH HAZARDS: NOT AN IRRITANT WHEN TESTED AS
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INGEST: IF ACCIDENTALLY SWALLOWED, DILUTE BY DRINKING LRE
QUANTITIES OF WATER. IMMED CONTACT POISON CONTROL CENTER/HOSPITAL
EMERGENCY ROOM FOR ANY OTHER ADDNL TREATMENT DIRECTIONS. EYES:
CALL A PHYS. SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD .
INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF RESP .
* Fire Fighting Measures *
Extinguishing Media:IN CASE OF FIRE, USE WATER SPRAY, DRY CHEMICAL,
FOAM OR CO*2.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER TO KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:WILL NOT BURN UNLESS WATER HAS
EVAPORATED.
* Accidental Release Measures *
Spill Release Procedures:SOAK UP WITH ABSORBENT MATERIAL AND REMOVE TO
A CHEMICAL DISPOSAL AREA. PREVENT ENTRY INTO NATURAL BODIES OF
WATER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE IN A
COOL, DRY PLACE. HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE
AND SAFETY PRACTICES.
Other Precautions:
* Physical/Chemical Properties *
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:NOT KNOWN
Appearance and Odor:WHITE MILKY LIQUID, MILD ACETIC AROMA
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:
Hazardous Decomposition Products:
* Disposal Considerations *
Waste Disposal Methods:RECOVER FREE LIQUID. ABSORB RESIDUE AND DISPOSE
OF ACCORDING TO LOCAL, STATE AND FEDERAL REQUIREMENTS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE.
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM CHLORIDE
Fraction by Wt: 1%M
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILVER CHLORIDE
Fraction by Wt: TRACE
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:SKIN: WASH AFFECTED AREAS WITH WATER. EYE: IMMED FLUSH WITH
INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF RESP) .
INGEST: CALL MD IMMED .
* Fire Fighting Measures *
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:ABSORB AND DISCARD IN TRASH, FLUSH DOWN DRAIN.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:NO SPECIAL PRECAUTIONS.
Other Precautions:NONE.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:0.6
Evaporation Rate & Reference:1(H*2O=1)
Solubility in Water:WATER SOLUTION
Appearance and Odor:CLEAR COLORLESS SOLUTION
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:
Hazardous Decomposition Products:NONE.
* Disposal Considerations *
Waste Disposal Methods:FLUSH DOWN DRAIN. DISPOSE OF I/A/W FEDERAL,
STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED HIGH EFFICIENCY PARTICULATE
RESPIRATOR FOR ORDINARY USE & NIOSH/MSHA APPROVED SCBA FOR
EMERGENCY USE.
Ventilation:LOCAL EXHAUST:FUME HOOD. MECHANICAL VENTILATION ADEQUATE.
Other Protective Equipment:LAB COAT & APRON, FLAME & CHEM RESISTANT
COVERALLS, EYEWASH CAPABLE OF SUSTAINED FLUSHING, SFTY DRENCH
SHOWER (SUPDAT)
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
OTHER PROT EQUIP:& HYGIENIC FACILITIES FOR WASHING.
* Product Identification *
CAGE:0MMA6
CAGE:0MMA6
* Composition/Information on Ingredients *
Ingred Name:MANGANESE (II) CHLORIDE (1:2)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHRONIC EXPOSURE TO MANGANESE FUMES OR
DUST CAN PRODUCE LANGUOR, SLEEPINESS, WEAKNESS IN LEGS, MUSCULAR
TWITCHINGS, FINE HAND TREMORS & NOCTURNAL CRAMPS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:REMOVE FROM EXPOSURE. EYES:FLUSH W/COPIOUS AMOUNTS OF WATER
INGEST/INHAL:SEEK PROMPT , COMPETENT MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:WATER, CO*2, DRY CHEMICAL EXTINGUISHING AGENTS, DRY
SAND, OR DRY GROUND DOLOMITE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. IF W/OUT RISK, REMOVE MATL FROM FIRE AREA. COOL CNTNR W/WATER
FROM MAXIMUM DISTANCE.
Unusual Fire/Explosion Hazard:NO UNUSUAL HAZARDS.
* Accidental Release Measures *
Spill Release Procedures:WEARING FULL PROTECTIVE CLOTHING & NIOSH/MSHA
APPROVED RESPIRATORY PROTECTION, STOP LEAK IF W/OUT RISK. COVER
SPILL W/SODIUM, BICARBONATE & CAREFULLY TRANSFER TO WELL-MARKED
CONTAINER. CLOSE CONTAINERTIGHTLY. SUBMIT OR RETAIN FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN COOL, DRY, WELL-VENTILATED AREA. PROTECT FROM PHYSICAL DAMAGE.
Other Precautions:WARNING! TOXIC IF INHALED OR INGESTED. AVOID EYE &
SKIN CONTACT.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:SOLUBLE
Appearance and Odor:ROSE-COLORED CRYSTALS, DELIQUESCENT.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
POTASSIUM, SODIUM, ZINC, MOISTURE.
Stability Condition to Avoid:AVOID CONTACT W/INCOMPATIBILITES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:CONSULT STATE, LOCAL & FEDERAL REGULATIONS FOR
PROPER DISPOSAL.
| 1 | gloves_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Item Description Information
*
Item Name: CONNECTOR,PLUG,FIBER OPTIC
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
& CALL MD. SKIN: HOT MATERIAL: IMMEDIATELY FLUSH W/COLD WATER & COVER
W/CLEAN DRESSING. DO NOT ATTEMPT TO REMOVE MATERIAL. HAVE BURN T REATED BY
MD. INHAL: POTENTIAL FOR VAPOR RELEASE WHEN CONNECTORS ARE HEATED IS MINIMAL.
SHOULD SYMPTOMS OCCUR, REMOVE TO FRESH AIR. IF SYMPTOMS CONTINUE, CALL MD.
INGEST: CALL MD IMMED (FP N).
*
Handling and Disposal
*
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF WASTE MATERIAL AND USED CONNECTORS IN A
SANITARY LANDFILL. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS (FP N).
Handling And Storage Precautions: AVOID CONTACT WITH HOT MATERIAL. KEEP OUT OF
REACH OF CHILDREN. FOR INDUSTRIAL USE ONLY.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: CARBON DIOXIDE, FOAM, WATER, DRY CHEMICAL.
Fire Fighting Procedures: NONE. WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
*
*
Respiratory Protection: USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: EMERGENCY EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: TRADE NAME/PART #: FIBER OPTIC CONNECTOR. USERS
OF THE "L" VERION OFSHOULD CONSULT "LR" VERSION FOR ADDITIONAL INFORMATION
(FP N).
*
Physical/Chemical Properties
*
Solubility in Water: NIL
Appearance and Odor: SOLID, BLUE, MILD RESINOUS ODOR
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: MATERIAL WILL GENERATE CARBON MONOXIDE,
CARBON DIOXIDE, NITROGEN OXIDES AND SMOKE PARTICLES WHEN SUBJECTED TO FLAME.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Review IND: Y
*
Detail DOT Information
*
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail IMO Information
*
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
*
Detail IATA Information
*
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail AFI Information
*
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
HAZCOM Label
*
Company Name: MINNESOTA MINING AND MFG CO ENGINEERING DOCUMENT SYSTEMS DIV
Street: 3M CTR
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR LEAD, IF
Ventilation:USE ENOUGH VENTILATION (GENERAL/LOCAL) TO KEEP THE FUMES
FROM THE WORKERS BREATHING ZONE & BELOW PEL. HEPA FILTERS REQD.
Other Protective Equipment:AS REQUIRED TO AVOID CONTACT.
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING OR SMOKING.
LAUNDER CONTAMINATIED CLOTHING BEFORE REUSE. FOLLOW GOOD HYGIENIC
PRACTICES.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:LEAD (SARA III)
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TIN
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
Ingred Name:ANTIMONY (SARA III)
Fraction by Wt: <2.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3
Ingred Name:ROSIN ACID
Fraction by Wt: 0.5-3%
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MOLTEN SOLDER ALLOYS DO NOT PRODUCE
AIRBORNE OR INGESTED LEAD MAY PRODUCE SYMPTOMS OF ANEMIA,
INSOMINIA, WEAKNESS, CONSTIPATION, NAUSEA & ABDOMINAL PAIN.
PROLONGED EXPOSURE MAY RESULT IN KIDNEY & NERVOUS SYSTEM
INVOLVEMENT. PREGNANT WOMEN SHOULD AVOID LEAD.
Explanation of Carcinogenicity:NOT LISTED BY NTP, IARC OR OSHA AS A
CARCINOGEN.
Effects of Overexposure:LOSS OF APPETITE, METALLIC TASTE IN THE MOUTH,
ANXIETY, CONSTIPATION, NAUSEA, PALLOR, EXCESSIVE TIREDNESS,
WEAKNESS, INSOMNIA, HEADACHE, NERVOUS IRRITABILITY, MUSCLE AND
JOINT SORENESS, TREMORS, DIZZI NESS, AND ABDOMINAL PAIN. WHEN
HEATED, FUMES MAY CAUSE EYE, SKIN & RESPIRATORY TRACT IRRITATION.
SOLDER CAN CAUSE BURNS.
Medical Cond Aggravated by Exposure:DISEASES OF THE BLOOD-FORMING,
NERVOUS, URINARY, RESPIRATORY AND REPRODUCTIVE SYSTEMS. EXPOSURE TO
LEAD MAY RESULT IN INJURY TO A DEVELOPING FETUS.
* First Aid Measures *
First Aid:IF A PERSON BREATHES IN A LARGE AMOUNT OF ROSIN FUME, REMOVE
FROM EXPOSURE. IF BREATHING IS DIFFICULT, ADMINISTER OXYGEN AND
CALL A PHYSICIAN. IF LEAD HAS BEEN INGESTED, IMMEDIATELY CALL A
PHYSICIAN.NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
FOR EYE BURNS, FLUSH IMMEDIATELY WITH COOL WATER AND OBTAIN MEDICAL
AID. FOR SKIN BURNS, COOL WITH WATER AND OBTAIN MEDICAL AID.
* Fire Fighting Measures *
Flash Point:NON FLAMMABLE
Autoignition Temp:Autoignition Temp Text:NONE
Extinguishing Media:USE DRY SAND OR DRY CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:SOLID AT ROOM TEMPERATURE. IF IN MOLTEN STATE,
ALLOW TO COOL AND SOLIDIFY AND THEN SCRAPE UP. VACUUM UP SMALL
PARTICLES. NEVER USE ANY METHOD WHICH WILL GENERATE DUST.
*Handling and Storage *
Handling and Storage Precautions:NO SPECIAL REQUIREMENTS FOR STORAGE.
READ ALL CONTAINER LABELING. FOOD AND DRINK SHOULD NOT BE CONSUMED
OR TOBACCO PRODUCTS USED WHERE SOLDER IS USED.
Other Precautions:AVOID CONTACT WITH FUMES AND DUST.
* Physical/Chemical Properties *
HCC:T4
Vapor Pres:0
Solubility in Water:NEGLIGIBLE
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:THE SMOKE FROM A SOLDERING OPERATION
MAY INCLUDE CARBON MONOXIDE, ABIETIC ACID, ALIPHATIC ALDEHYDES &
DITERPENE ACIDS.
* Disposal Considerations *
Waste Disposal Methods:RECLAIM ALLOY OR DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE & LOCAL LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE EITHER A SELF-CONTAINED BREATHING APPARATUS OR
A NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC VAPORS,DEPENDING ON
THE AIRBORN CONCENTRA TION.
Ventilation:LOCAL VENTILATION AT THE WORKSITE;MECHANICAL(GENERAL)
VENTILATION TO MAINTAIN TLV/PEL.USE EXPLOSION PROOF EQUIPMENT.
Other Protective Equipment:WEAR NITRILE COATED CLOTHING IF PROLONGED
SKIN CONTACT IS ANTICIPATED.PROVIDE A LOCAL EYE WASH STATION AND
SAFETY SHOWER
Work Hygienic Practices:USE REASONABLE CARE IN HANDLING THIS
PRODUCT.WASH HANDS AFTER USE AND BEFORE EATING.
Supplemental Safety and Health
THIS ITEM IS SUPPLIED AS A KIT.
* Product Identification *
CAGE:0UKB6
* Composition/Information on Ingredients *
Ingred Name:ETHYL ETHER (SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:ETHYLENE (SARA III)
Fraction by Wt: 6.5%
Other REC Limits:NONE SPECIFIED
Ingred Name:ETHYL ALCOHOL (ETHANOL)
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
Ingred Name:2,6-DI-TERT-BUTYL-4-METHYLPHENOL, 1PPM
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRITATION.SKIN:MAY
CAUSE IRRITATION AND DEFATTING.INGEST:MODERATLEY TOXIC BY
INGESTION.INHAL:MAY CAUSE RESPIRATORY IRRITATION AND CNS EFFECTS.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:EYES:ACUTE
CONJUNCTIVITIS.INHAL:HEADACHE,DIZZINESS,ANOREXIA,NAUSEA,VOMITING,LA
SSITUDE.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
AILMENTS MAY BE AT INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH COOL
EYES.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN OR ARTIFICIAL
RESPIRATION(PREFERABLY MOUTH-TO-MOU TH) IF NEEDED.INGEST:DO NOT
INDUCE VOMITING.GET PROMPT QUALIFIED MEDICAL ATTENTION.IF
CONSCIOUS,QUICKLY GIVE WATER OR MILK.DO NOT GIVE SODIUM
BICARBONATE,VINEGAR OR FRUIT JUICE.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:1.9
Extinguishing Media:DRY CHEMICAL, FOAM OR CARBON DIOXIDE.WATER MAY BE
AN INEFFECTIVE EXTINGUISHANT.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR,CAN TRAVEL
DISTANCES ALONG THE GROUND,AND FLASHBACK AT THE
SOURCE.DECOMPOSITION PRODUCTS MAY BE TOXIC.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION.USE PROPER
RESPIRATORY AND PROTECTIVE EQUIPMENT.VENTILATE AREA.SOAK UP WITH A
NON-COMBUSTIBLE INERT ABSORBANT(CLAY,SAND);PLACE IN PROPER
CONTAINER FOR DISPOSAL.RUNOFF TO SEWER MAY CREATE EXPLOSION
HAZARD.
Neutralizing Agent:NONE
*Handling and Storage *
CONBUSTIBLES. PROTECT CONTAINER FROM PHYSICAL DAMAGE.
Other Precautions:SMOKING SHOULD BE PROHIBITED IN STORAGE AREAS.FOLLOW
LABEL DIRECTIONS.USE WITH PROPER VENTILATION.AVOID SKINA ND EYE
CONTACT.DO NOT INHALE VAPORS.
* Physical/Chemical Properties *
HCC:G2
NRC/State Lic Num:NONE
Vapor Density:2.6
Evaporation Rate & Reference:6.9 (REFERENCE NOT GIVEN)
Solubility in Water:MODERATE
Appearance and Odor:AEROSOL.LIQUID IS COLORLESS WITH A SWEET ETHEREAL
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
FORMS EXPLOSIVE PEROXIDES WHEN EXPOSED TO AIR,LIGHT OR EVAPORATED
TO DRYNESS.
Hazardous Decomposition Products:CARBON MONOXIDE AND OTHER ALDEHYDES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.ALLOW SPILLS TO EVAPORATE. ALLOW CYLINDER
CONTENTS TO BE USED COMPLETELY, THEN DISPOSE OF IN NORMAL TRASH. DO
NOT PUNCTURE, MUTILATE, OR INCINERATE CONTAINER.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR SPECIFIED FOR
PROTECTION AGAINST PAINT SPRAY DUST AND SANDING DUST IN RESTRICTED
OR CONFINED AREAS.
Ventilation:ADEQUATE TO MAINTAIN WORKING ATMOSPHERE BELOW T.L.V. AND
L.E.L. MECHANICAL EXHAUST MAY BE REQUIRED IN CONFINED AREAS.
Other Protective Equipment:CLOTHING ADEQUATE TO PROTECT SKIN.
Work Hygienic Practices:REMOVE AND WASH CLOTHING BEFORE REUSE. WASH
HANDS BEFORE EATING, SMOKING OR USING THE WASHROOM.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 2.1-2.2%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)
Fraction by Wt: 1.6-2.9%
OSHA PEL:SEE TABLE Z3
Ingred Name:STODDARD SOLVENT; (ODORLESS MINERAL SPIRITS). VP: 1.2 @
Fraction by Wt: 1.4-1.5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: IRRITATION OF THE
RESPIRATORY TRACT. SKIN & EYE: PRIMARY IRRITATION. INGEST:
INGESTION OF LARGE AMOUNTS COULD CAUSE SERIOUS INJURY. POSSIBLE
ANESTHETIC EFFECT FROM MINERAL SPIRITS CONTEN T. CHRONIC: NONE
KNOWN.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE (QUARTZ): GROUP 2
(NTP), GROUP 2A (IARC).
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE EXPECTED WHEN USED IN
ACCORDANCE WITH MSDS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. GET MEDICAL HELP FOR ANY
BREATHING DIFFICULTY. EYE: FLUSH THOROUGHLY WITH WATER FOR AT LEAST
1 OR 2 GLASS ES OF WATER TO DILUTE. DO NOT INDUCE VOMITING. CALL
MD.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . COOL EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE. TOXIC GASES MAY FORM WHEN PRODUCT BURNS.
* Accidental Release Measures *
Spill Release Procedures:FLUSH WITH WATER. ABSORB WITH SAWDUST OR RAGS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT THROW OR DROP CONTAINERS.
Other Precautions:AVOID CONTACT WITH EYES AND PROLONGED CONTACT WITH
SKIN OR BREATHING OF SPRAY MIST OR SANDING DUST. CLOSE CONTAINER
AFTER EACH USE. KEEP OUT OF REACH OF CHILDREN. DO NOT TAKE
INTERNALLY.
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:1.3
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:ELEVATED TEMPERATURES.
Hazardous Decomposition Products:BURNING MAY PRODUCE CO & CO*2.
* Disposal Considerations *
Waste Disposal Methods:CONVENTIONAL PROCEDURES IN COMPLIANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT INCINERATE SEALED
CONTAINERS.
| 1 | gloves_mandatory |
Control Measures
*
Cage: KULZR
*
Preparer Co. when other than Responsible Party Co.
*
Cage: KULZR
*
Contractor Summary
*
Cage: EKAKT
Cage: KULZR
*
Ingredients
*
------------------------------
% Wt: 0-5
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: IRRITATING TO EYES. SKIN: IRRITATION TO MUCOUS MEMBRANES.
SENSITIZATION BY CONTACT.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION.
First Aid: INHALATION: SUPPLY FRESH AIR. SKIN: INSTANTLY WASH W/WATER &
SOAP & RINSE THOROUGHLY. EYES: RINSE OPENED EYE FOR SEVERAL MINS UNDER
RUNNING WATER. INGESTION: INITIATE VOMITING. OBTAIN MEDICAL ATTENTIO N IN ALL
CASES.
*
Handling and Disposal
*
Spill Release Procedures: WEAR PROTECTIVE EQUIPMENT. KEEP UNPROTECTED PERSONS
AWAY. DON'T ALLOW PRODUCT TO REACH SEWAGE SYSTEM/WATER BODIES. PREVENT
MATERIAL FROM REACHING SEWAGE SYSTEM, HOLES & CELLARS. ABSORB W/LIQUID
BINDIN G MATERIAL (DIATOMITE/UNIVERSAL BINDERS/SAWDUST).
Waste Disposal Methods: MUST NOT BE DISPOSED TOGETHER W/HOUSEHOLD GARBAGE.
DON'T ALLOW PRODUCT TO REACH SEWAGE SYSTEM. DISPOSE OF IAW/FEDERAL, STATE
Handling And Storage Precautions: KEEP CONTAINERS TIGHTLY SEALED. KEEP IGNITION
SOURCES AWAY-DON'T SMOKE. INITIATE MEASURES AGAINST ELECTROSTATIC CHARGING.
KEEP COOL NOT > ROOM TEMP.
Other Precautions: AVOID CONTACT W/EYES & SKIN. KEEP AWAY FROM FOODSTUFFS,
BEVERAGES & FOODS.
*
Fire and Explosion Hazard Information
*
Lower Limits: 2.1
Extinguishing Media: CO2, EXTINGUISHING POWDER/WATER JET. LARGER FIRES: WATER
JET/ALCOHOL-RESISTANT FOAM
Unusual Fire/Explosion Hazard: FORMATION OF TOXIC GASES IS POSSIBLE DURING
*
*
Respiratory Protection: IF EXPOSURE TO VAPORS IS POSSIBLE, USE BREATHING
PROTECTIVE MASK (FILTER A).
Work Hygienic Practices: WASH HANDS DURING BREAKS & AT THE END OF THE WORK DAY.
INSTANTLY REMOVE ANY SOILED & IMPREGNATED GARMETS.
*
Physical/Chemical Properties
*
Solubility in Water: NOT MISCIBLE
Appearance and Odor: COLORLESS FLUID W/CHARACTERISTIC ODOR
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: FIRE. STORAGE LONGER THAN/ABOVE RECOMMENDED
TEMPERATURE.
Hazardous Decomposition Products: FLUE GASES, HEAT
Hazardous Polymerization Indicator: YES
Conditions To Avoid Polymerization: PRODUCT IF STORED LONGER THAN/ABOVE
RECOMMENDED TEMPERATURE MAY POLYMERIZE GENERATING HEAT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Cage: KULZR
Company Name: HERAEUS KULZER GMBH
Label Required IND: Y
Status Code: C
Origination Code: G
Hazard And Precautions: IRRITATING TO EYES, RESPIRATORY SYSTEM & SKIN. MAY
CAUSE SENSITIZATION BY SKIN CONTACT.
IRRITATION.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE NIOSH APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . PROTECTIVE CLOTHING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM DEXTRAN SULFATE
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DEXTRAN IS A POTENT ANTIGEN.
OVEREXPOSURE CAN CAUSE A TEMPORARY INCREASE IN CARDIAC OUTPUT.
Effects of Overexposure:SEE HEALTH HAZARDS.
* First Aid Measures *
First Aid:INGESTION: WASH OUT MOUTH WITH WATER PROVIDED PERSON IS
CONSCIOUS. CALL A PHYSICIAN. SKIN: FLUSH WITH COPIOUS AMOUNTS OF
SHOES. CALL A P HYSICIAN. INHALATION: REMOVE TO FRESH AIR. IF
BREATHING BECOMES DIFFICULT, CALL A PHYSICIAN. EYES: FLUSH WITH
FLUSHING BY SEPARATING T HE EYELIDS WITH FINGERS. CALL A PHYSICIAN.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. SWEEP UP, PLACE IN
A BAG AND HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE
AREA AND WASH SPILL SITE AFTER MATERIAL PICKUP IS COMPLETE.
* Physical/Chemical Properties *
Solubility in Water:SOLUBLE
Appearance and Odor:SOLID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
TOXIC FUMES OF CARBON MONOXIDE, CARBON DIOXIDE, SULFUR OXIDES.
Hazardous Decomposition Products:NO
* Toxicological Information*
ORGAN DATA: BEHAVIORAL (SOMNOLENCE, ATAXIA); LUNGS, THORAX OR
RESPIRATION (RESPIRATORY DEPRE SSION). ONLY SELECTED REGISTRY OF
TOXIC EFFECTS OF CHEMICAL SUBSTANCES (RTECS) DATA IS PRESENTED
HERE. SEE ACTUAL ENTRY IN RTECS FOR COMPLETE INFORMATION.
* Ecological Information *
Ecological:DATA NOT YET AVAILABLE.
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
MATERIAL AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
* MSDS Transport Information *
Transport Information:CONTACT SIGMA CHEMICAL COMPANY FOR TRANSPORATION
INFORMATION.
* Regulatory Information *
Federal Regulatory Information:EUROPEAN INFORMATION: CAUTION: SUBSTANCE
NOT YET FULLY TESTED. REVIEWS, STANDARDS, AND REGULATIONS: OEL=MAK.
EPA TSCA SECTION 8 (B) CHEMICAL INVENTORY.
State Regulatory Information:
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF WORKPLACE EXPOSURE LIMIT(S) OF PROD OR ANY
COMPONENT IS EXCEEDED (SEE TLV/PEL), A NIOSH/MSHA APPRVD AIR
SUPPLIED RESPIRATOR IS ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL
CONTROL. OSHA REGS ALSO PER MIT OTHER NIOSH/MSHA APPRVD (SUPP DATA)
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH AND SAFETY EQUIPMENT SHOULD BE
READILY AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
RESP PROT: RESP (NEGATIVE PRESSURE TYPE) UNDER SPECIFIED CNDTNS (SEE
YOUR SAFETY EQUIP SUPPLIER). ENGINEERING &/OR ADMINISTRATIVE
CONTROLS SHLD BE IMPLEMENTED TO REDUCE EXPOSURE. SPILL PROC: THIS
CAN BE DONE WITHOUT RISK. TAKE UP AND CONTAINERIZE FOR PROPER
DISP. COMPLY W/FED, STATE & LOC REGS ON REPORTING RELEASES.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:HEXADECANE
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NARCOTIC IN HIGH CONCENTRATIONS. VAPOR
IRRITATING TO EYES AND RESPIRATORY PASSAGES. MAY CAUSE SKIN
IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS.
* First Aid Measures *
First Aid:GET MED ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:
IMMEDIATELY FLUSH THOROUGHLY WITH LARGE AMOUNTS OF WATER. EYES:
REMOVE TO FR ESH AIR; GIVE ARTIFICIAL RESPIRATION IFBREATHING HAS
STOPPED. INGEST: DO NOT INDUCE VOMITING; GET IMMEDIATE MEDICAL
ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MODERATE FIRE HAZARD.
* Accidental Release Measures *
Spill Release Procedures:EVAC AREA OF ALL UNNEC PERSONNEL. WEAR
SUITABLE PROT EQUIP LISTED UNDER EXPOS/PERSONAL PROTECTION. ELIM
ANY IGNIT SOURCES UNTIL AREA IS DETERMINED TO BE FREE FROM
EXPLOSION OR FIRE HAZARDS. CONTAIN TH E RELEASE & ELIMINATE ITS
SOURCE, IF (SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CNTNR CLSD. STORE IN A COOL, DRY
AREA AWAY FROM IGNITION SOURCES & OXIDIZERS. DO NOT BREATHE VAPOR.
DO NOT GET IN EYES, ON SKIN, OR ON CLTHG.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:HEAT; CONTACT WITH IGNITION SOURCES.
Hazardous Decomposition Products:OXIDES OF CARBON.
* Disposal Considerations *
Waste Disposal Methods:ALWAYS CONTACT A PERMITTED WASTE DISPOSER (TSD)
TO ASSURE COMPLIANCE WITH ALL CURRENT LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED SUPPLIED AIR RESPIRATORY
PROTECTION FOR CLEANING LGE SPILLS OR UPON ENTRY INTO TANKS,
VESSELS, OR OTHER CONFINED SPACES.
Ventilation:UNDER NORMAL APPLICATIONS OF THIS PRODUCT NO VENTILATION IS
REQUIRED.
Other Protective Equipment:IMPERVIOUS PROTECTIVE CLOTHING MADE OF
NEOPRENE, NITRILE OR N-BUTYL RUBBER IS SUITABLE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:VAPS & TO PROVIDE PROT FOR PERSONS ATTEMPTING TO STOP
THE LEAK. OTHER PREC:INJURY OR DEATH. DO NOT ATTEMPT TO CLEAN SINCE
RESIDUE IS DFCLT TO REMOVE. EMPTY DRUMS SHOULD BE COMPLETELY D
RAINED, PROPERLY BUNGED & PROMPTLY RETURNED TO DRUM RECONDITIONER.
ALL OTHER CNTNRS SHOULD BE DISP OF IN ENVIRON (ING 2)
* Product Identification *
Product ID:DIESEL
CAGE:0BET2
CAGE:0BET2
* Composition/Information on Ingredients *
Ingred Name:COMPLEX MIXTURE OF HYDROCARBONS
Ingred Name:SUPP DATA:SAFE MANNER IN ACCORDANCE WITH GOVERNMENTAL
REGULATIONS. DO NOT GET IN EYES. DO NOT (ING 3)
Ingred Name:ING 2:GET ON SKIN OR CLOTHING.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:MAY CAUSE SLIGHT IRRITATION.
INGEST: EXPECTED TO HAVE SLIGHT ACUTE TOXICITY BY INGESTION.
INHAL:MAY CAUSE SYMPTOMS OF DROWSINESS OR NARCOSIS FROM INHALATION
OF HIGH VAPOR CONCENTRATIONS. SKIN:PRIM ARY IRRITANT; EXTREMELY
IRRITATING TO SKIN W/BURNS AND BLISTERING POSSIBLE. PROLONGED OR
REPEATED SKIN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:CONTACT MAY BE HARMFUL. SKIN
SENSITIZER. NOTE TO MD:INGESTION OF PROD & SUBSEQUENT VOMIT CAN
RSLT IN ASPIR OF LIGHT HYDROCARBON LIQ WHICH CAN CAUSE PNEUMONITIS.
CHRONIC:MIDDILE DISTILLATE HAS CAUSED CANCER IN LAB ANIMALS.
BRIEF/INTERMITTENT SKIN CNTCT NOT EXPECTED TO CAUSE ANY ADVERSE
EFTS IF WASHED FROM SKIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
WHILE HOLDING EYELIDS OPEN. SKIN:WASH THOROUGHLY WITH SOAP & WATER.
INGEST:DO NOT INDUCE VOMITING. ASPIRATION OF FLUID CAN CAUSE
SERIOUS LUN G INJURY SUCH AS CHEMICAL PNEUMONITIS. CALL MD IMMED.
INHAL:IF SYMPTOMS OF BREAHTING DIFFICULTY OCCUR, MOVE TO FRESH AIR.
IF BREATHING STOPPED, APPLY ARTIFICIAL RESPIRATION. CALL MD.
* Fire Fighting Measures *
Flash Point Method:PMCC
Upper Limits:4.1%
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM, OR CARBON DIOXIDE.
WATER OR FOAM MAY CAUSE FROTHING.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. USE WATER TO COOL FIRE-EXPOSED CNTNRS. IF LEAK/SPILL HAS NOT
IGNITED, USE WATER SPRAY TO DISPERSE (SUPDAT)
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. AVOID BREATHING VAPOR. USE
NIOSH/MSHA APPROVED SUPPLIED AIR RESPIRATOR FOR LARGE SPILLS IN
CONFINED AREA. CONTAIN SPILL IF POSSIBLE. WIPE UP OR ABSORB ON
SUITABLE MATERIAL AND SHOVEL U P.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, AND
FLAME. TRANSPORT, HANDLE AND STORE IN ACCORDANCE WITH LOCAL
REGULATIONS REGARDING COMBUSTIBLE LIQUID.
Other Precautions:EMPTY CNTNRS RETAIN RESIDUE (LIQ &/OR VAP) & CAN BE
DANGEROUS. DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND OR EXPOSE SUCH CNTNRS TO HEAT, FLAME, SPARKS, STATIC ELEC, OR
OTHER SOURCES OF IGNIT. THEY MAY EXPLO & CAUSE(SUPP DATA)
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:LOW
Solubility in Water:NIL
Appearance and Odor:CLEAR AND BRIGHT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO AND CO2 MAY BE FORMED ON BURNING IN
LIMITED AIR SUPPLY.
* Disposal Considerations *
Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS AND DISPOSE OF IN MANNER CONSISTENT WITH APPLICABLE
REGULATIONS. CONTACT LOCAL ENVIRONMENTAL OR HEALTH AUTHORITIES FOR
APPROVED DISPOSAL OF MATERI AL. DISP MUST BE I/A/W LOC/STATE & FED
REGS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NORMALLY NONE REQUIRED. IF HIGH VAPOR OR MIST
CONCENTRATIONS ARE EXPECTED, USE APPROPRIATE NIOSH APPROVED
RESPIRATOR FOR ORGANIC VAPORS AND MISTS.
Ventilation:LOCAL - TO MAINTAIN EXPOSURE LEVELS BELOW RECOMMENDED
LIMITS. MECHANICAL - IN CONFINED SPACES.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
BODY-COVERING WORK CLOTHES TO AVOID PROLONGED EXPOSURE.
Work Hygienic Practices:ALWAYS FOLLOW GOOD HOUSEKEEPING AND PERSONAL
HYGIENE PRACTICES.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: PREMIUM BLEND (LOWER UNIT LUBRICANT).
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ADDITIVE PACKAGE (MIXTURE)
= Wt:7.
Ingred Name:POUR POINT ADDITIVE (MIXTURE)
= Wt:3.
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: LOW RISK OF INHALATION.
MISTS ABOVE TLV MAY CAUSE CHEMICAL PNEUMONITIS. SKIN/EYE: MILD
IRRITANT. INGESTION: LOW TOXICITY, RISK OF ASPIRATION INTO LUNGS.
INGESTION OF LARGE QUANTITIES MAY C AUSE SLIGHT GASTROINTESTINAL
DISCOMFORT, DIARRHEA AND HEADACHE. SMALL DOSES MAY PRODUCE
IRRITATION AND DIARRHEA.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE EXPECTED.
* First Aid Measures *
First Aid:INHALATION: IMMEDIATELY REMOVE TO FRESH AIR & CALL EMERGENCY
MEDICAL CARE. IF BREATHING HAS STOPPED, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE HUMIDIFIED OXYGEN.
SKIN: REMOVE CONTAM INATED CLOTHING. WASH CONTAMINATED SKIN WITH
MEDICAL ATTENTION IMMEDIATELY. INGESTION: DO NOT INDUCE VOMITING.
GET IMMEDIATE MEDICAL ASSISTANCE.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER MAY CAUSE FROTHING.
Unusual Fire/Explosion Hazard:PRODUCT IS A COMBUSTIBLE LIQUID. EMPTY
CONTAINERS MAY CONTAINS PRODUCT RESIDUE WHICH COULD INCLUDE
FLAMMABLE OR EXPLOSIVE VAPORS.
* Accidental Release Measures *
Spill Release Procedures:SMALL SPILL: REMOVE SOURCES OF HEAT OR
IGNITION. PROVIDE ADEQUATE VENTILATION. CONTAIN LEAK WITH
ABSORBENT, INERT, NON-COMBUSTIBLE MATERIAL. LARGE SPILL: CONTAIN
SPILL. TRANSFER TO SECURE CONTAINERS. IN THE EVENT OF AN
UNCONTROLLED MATERIAL RELEASE, THE USER SHOULD DETERMINE IF RELEASE
IS REPORTABLE UNDER APPLICABLE LAWS & REGULATIONS.
*Handling and Storage *
Handling and Storage Precautions:PRODUCT IS A COMBUSTIBLE LIQUID. KEEP
OR FLAME TO CONTAINER. KEEP SEPARATE FROM STRONG OXIDIZING AGENTS.
EMPTY CONTAINERS MAY CONTAI N PRODUCT RESIDUE WHICH COULD INCLUDE
FLAMMABLE OR EXPLOSIVE VAPORS.
Other Precautions:KEEP AWAY FROM CHILDREN!
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:NOT DETERMINED
Vapor Density:>1 (AIR=1)
Evaporation Rate & Reference:NOT DETERMINED (BU AC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER TO BROWN, OIL TYPE LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS.
Stability Condition to Avoid:KEEP AWAY FROM HIGH HEAT OR FLAME. KEEP
SEPARATE FROM STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON DIOXIDE (CARBON MONOXIDE UNDER
INCOMPLETE COMBUSTION).
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Toxicological Information*
7 HRS. EFFECTS OF BLOOD CELLS: LONG-TERM EXPOSURE TO
2-BUTOXYETHANOL CAN CAUSE BLOOD CHANGES, INCLUDING ANEMIA, IN RATS.
(SARA)
* Ecological Information *
BIODEGRADATION LIKELY TO BE THE MOST IMPORTANT REMOVAL MECHANISM OF
ETHYL ENE GLYCOL MONO-N-BUTYL ETHER FROM AEROBIC SOIL & WATER. IN
ATMOSPHERE, ETHYLENE GLYCOL MONO-N-BUTYL EXPECTED TO EXIST ALMOST
ENTIRELY IN THE VAPOR PHASE & REACTIONS W/PHOTOCHEMICALLY PRODUCED
PHYSICAL REMOVAL OF ETHYLENE GLYCOL MONO-N-BUTYL ETHER FROM AIR BY
PRECIPITATION & DISSOLUTION IN CLOUDS MAY OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF PRODUCT I/A/W FEDERAL, STATE AND
LOCAL REGULATIONS. BEFORE ATTEMPTING TO CLEAN UP, REFER TO OTHER
SECTIONS OF THIS MSDS FOR HAZARD CAUTION INFORMATION.
* MSDS Transport Information *
Transport Information:DOT & IATA: NOT RESTRICTED. FIRE/EXPLOSION HAZARD
(CONTD): MONOXIDE. GENERAL HAZARDS: VAPORS MAY BE IGNITED BY HEAT,
SPARKS, FLAMES, OTHER SOURCES OF IGNITION IF HEATED ABOVE
FLASHPOINT. VAPORS ARE HE AVIER THAN AIR AND MAY TRAVEL TO SOURCE
OF IGNITION AND FLASHBACK. CONTAINER MAY EXPLODE IN FIRE. EMPTY
CONTAINER MAY STILL CONTAIN RESIDUAL MATERIAL WHICH CAN IGNITE
AND/OR EXPLODE. DO NOT PRESSURIZE , CUT, WELD, BRAZE, SOLDER,
DRILL, GRIND OR EXPOSE EMPTY CONTAINER TO HEAT, FLAME, SPARKS,
STATIC ELECTRICITY OR OTHER SOURCES OF IGNITION.
* Regulatory Information *
SARA Title III Information:FOLLOWING COMPONENTS LISTED UNDER SECTION
2-BUTOXYETHANOL & ITS METABOLITE BUTOXYACETIC ACID CAN CAUSE
BREAKDOWN OF RED BLOOD CELLS. HUMANS APP EAR TO BE LESS SENSITIVE
TO THIS EFFECT THAN RATS. REPRODUCTIVE EFFECTS: 2-BUTOXYETHANOL HAS
PPM, W/NO APPARENT INCREASE IN CONGENITAL DEFECTS AMONG OFFSPRING.
IT DID NOT CAUSE TESTICULAR ATROPHY IN MALES. CHEMICAL
INTERACTIONS: NO INFORMATION FOUND.
Federal Regulatory Information:CERCLA: FOLLOWING COMPONENTS HAVE CERCLA
REPORTABLE QUANTITIES: NO CERCLA RQ CHEMICALS. WHMIS: FOLLOWING
COMPONENTS ARE WHMIS WORKPLACE HAZARDOUS MATERIALS: 2-BUTOXYETHANOL
COMPONENTS ARE SUBJ TO RCRA LAND D ISPOSAL RESTRICTIONS: NO
SUBSTANCES SUBJ TO RCRA LAND DISPOSAL RESTRICTIONS.
State Regulatory Information:N/P. FIRST AID (CONTD): CONTACTED
IMMEDIATELY AND BE PROVIDED WITH THIS MSDS. FOR INGESTION OF SMALL
QUANTITIES OF CHEMICALS, RISK ASSOCIATED WITH INDUCING VOMITING
USUALLY EXCEEDS POISONING RISK. GET MEDICAL ATTENTION IMMEDIATELY.
DRINK 2GLASSES WATER. CONTACT POISON INFORMATION SERVICE. STOMACH
EVALUATION MAY BE APPROPRIATE, AS RECOMMENDED BY MEDICAL
PROFESSIONALS, ONLY IF SIGNIFICANT QUANTITY O F MATERIALS HAVE BEEN
INGESTED. STOMACH EVACUATION SHOULD ONLY BE CARRIED OUT BY TRAINED
AND PROPERL Y EQUIPPED MEDICAL PERSONNEL.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SUPPLIED-AIR RESPIRATOR WITH FULL FACEPIECE,
HOOD.
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO KEEP BELOW TLV.
Other Protective Equipment:CONTAMINATION OF CLOTHING/PROLONGED/REPEATED
SKIN CONTACT.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SELENIOUS ACID (SARA III)
Fraction by Wt: <4%
OSHA PEL:0.2 MG SE/M3
Ingred Name:CUPRIC NITRATE
Fraction by Wt: <4%
ACGIH TLV:1 MG/CUM
Ingred Name:NITRIC ACID (SARA III)
Fraction by Wt: <2%
OSHA PEL:2 PPM/4 STEL
Ingred Name:PHOSPHORIC ACID (SARA III)
Fraction by Wt: <3%
OSHA PEL:1 MG/M3/3 STEL
Ingred Name:WATER
* Hazards Identification *
Effects of Overexposure:HEADACHE/DIZZINESS/LASSITUDE/TREMORS/DIFFICULTY
BREATHING/BRONCHITIS/PNEUMONITIS/BRONCHIAL ASTHMA.
* First Aid Measures *
First Aid:EYES: RINSE WITH CLEAN WATER. INHALATION: REMOVE FROM
EXPOSURE. IF BREATHING DIFFICULT/OXYGEN. INGESTION: IF VICTIM IS
CONSCIOUS/INDUCE VOMITING. SKIN: WASH AFFECTED AREAS WITH SOAP AND
WATER. REMOVE CONTAMINATED CLOTHING. SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:NON-FLAMMABLE
Fire Fighting Procedures:NON-FLAMMABLE
Unusual Fire/Explosion Hazard:NON-FLAMMABLE. NON-EXPLOSIVE EXCEPT WITH
WATER-REACTIVE SUBSTANCES.
* Accidental Release Measures *
Spill Release Procedures:RECOVER AS MUCH FREE LIQUID AS POSSIBLE AND
COLLECT IN ACID-RESISTANT CONTAINER. USEBSORBENT TO PICK UP
RESIDUE. AVOID DISCHARGING THE LIQUID DIRECTLY INTO SEWER OR
SURFACE WATERS.
*Handling and Storage *
Handling and Storage Precautions:AVOID CO-LOADING OR STORING WITH
CYANIDES, WATER-REACTIVE SUBSTANCES OR STRONG REDUCING AGENTSSTORE
IN ACID-RESISTANT CONTAINERS.
Other Precautions:PROTECT CONTAINERS FROM PHYSICAL DAMAGE. WORKERS
HANDLING THE PRODUCT SHOULD WASH BEFORE SMOKING OR EATING.
* Physical/Chemical Properties *
Vapor Density:<1
Evaporation Rate & Reference:(ETHYL ETHER=1):>1
Solubility in Water:MISCIBLE
Appearance and Odor:ODORLESS BLUE LIQUID.
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CYANIDES/WATER-REACTIVE/ORGANIC SOLVENTS/OILS/REDUCERS_
Hazardous Decomposition Products:SELENIUM DIOXIDE FUMES/OXIDES OF
NITROGEN/PHOSPHORUS.
* Disposal Considerations *
Waste Disposal Methods:THE WASTES CAN BE DISPOSED OF THROUGH A LICENSED
WASTE DISPOSAL COMPANY.
_
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AS REQUIRED
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:WASH AFTER USE. REMOVE/LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. DON'T CONSUME FOOD/BEVERAGE WHERE PRODUCT IS
USED.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:DICK KARBO
CAGE:KMADD
CAGE:KMADD
* Composition/Information on Ingredients *
Ingred Name:COPPER COMPOUND
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT W/SKIN/EYES CAN
CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
* First Aid Measures *
First Aid:EYES: FLUSH IMMEDIATELY W/WATER. SKIN: WASH AFFECTED AREA
W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
* Accidental Release Measures *
Spill Release Procedures:SMALL: WIPE UP & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS. LARGE: SCOOP MATERIAL INTO SEALABLE
CONTAINERS. WIPE UP REMAINDER & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
* Physical/Chemical Properties *
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:INSOLUBLE
Appearance and Odor:OILY
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYEBATH, WASHING FACILITIES, SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS WELL AFT HNDLG.FOLLOW GOOD HYGIENE
PRAC TO MIN SKIN/EYE CONTACT.
Supplemental Safety and Health
CONDITIONS TO AVOID:SIMILAR FUNCTIONAL GROUPS FORM PEROXIDES OF UNK
STABILITY.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ETHYL-3-ETHOXYPROPIONATE
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:EXPECTED TO BE A LOW HAZARD FOR
USUAL INDUSTRIAL OR COMMERCIAL HNDLG BY TRAINED PERSONNEL.
EYES/SKIN:EXPECTED TO BE LOW HAZ FOR USUAL INDUSTRIAL OR COMMERCIAL
HNDLG BY TRAINED PERSONNEL. INGEST: EXPECTED TO BE LOW INGESTION
HAZARD.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY
CLASSIFICATION:IARC/ACGIH/NTP/OSHA:NONE.
Effects of Overexposure:EXPECTED TO BE LOW HAZARD FOR
INDUSTRIAL/COMMERCIAL HNDLG BY TRAINED PERSONNEL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:IF SYMPTOMATIC MOVE TO FRESH AIR.TREAT
SYMPTOMATICALLY.GET MED ATTN IF SYMPTONS PERSIST. EYES:ANY MATL
THAT CONTACTS EYE SHOULD BE WASHED OUT IMMED W/WATER.GET MED ATTN
IF SYMPTOMS OCCUR. SKIN:W ASH W/SOAP & WATER.GET MED ATTN IF
SYMPTOMS OCCUR. INGEST:DRINK 1-2 GLASSES OF WATER.SEEK MED
ATTN.NEVER GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE (CO2), DRY CHEMICAL,
ALCOHOL FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.USE WATERSPRAY TO KEEP FIRE-EXPO CNTNRS
COOL.FIRE/EXCESSIVE HEAT MAY PRODUCE HAZ DECOMPO PRODUCTS.
Unusual Fire/Explosion Hazard:CLASSIFIED AS COMBUSTIBLE.MATL CONTAINS
COMBUST SOLVENT THAT MAY ACCUMULATE IN CNTNR HEADSPACE.ELEVATED
TEMP CAN CAUSE DECOMP.MAY FORM PEROXIDES OF UNK STABILIT
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES.ABSORB
W/VERMICULITE OR OTHER INERT MATERIAL, THEN PLACE IN CONTAINER FOR
CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL
CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID PROLON/REP BREATH OF VAP &
CONTACT W/SKIN.AVOID CONTACT W/EYES.USE W/ADEQUATE VENTI.KEEP AWAY
FRM HEAT/FLAME.KEEP FRM CONTACT W/OXIDIZING MATLS.
Other Precautions:MIN EXPO TO AIR.IF PEROXIDE FORMATION IS SUSPECTED DO
NOT OPN/MOVE CNTNR.KEEP CNTNR TIGHTLY CLSD.STORE IN COOL PLACE AWAY
FRM HEAT/LIGHT.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:N/AVAILABL
Vapor Density:N/AVAILABL
pH:N/AVAI
Solubility in Water:MISCIBLE
Appearance and Odor:LIQUID, RED COLOR, ODOR NOT AVAILABLE.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
>RM TEMP.NORMALLY STABLE HOWEVER ON LONG TERM STORAGE MATL
CONTAINING (SUPPLEM)
Hazardous Decomposition Products:NONE SPECIFIED BY MFG. HAZ COMBUST
PROD:CO2, CO,OXIDES OF NITROGEN,OXIDES OF SULFUR,HYDROGEN CHLORIDE.
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE/TREATMENT/DISPOSAL MAY BE SUBJECT TO
NATIONAL/STATE/LOCAL LAWS. INCINERATE. SINCE EMPTIED CNTNR RETAIN
PROD RESIDUE FOLLOW LABEL WARNINGS EVEN AFT CNTNR IS EMPTIED. CHEM
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR EMERGENCY OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR OR SUPPLIED
Ventilation:USE ADEQUATE EXPLOSION-PROOF MECHANICAL VENTILATION TO
MAINTAIN EXPOSURE BELOW REGULATORY LIMITS.
Other Protective Equipment:EYE WASH STATION AVALABLE. RUBBER APRON.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
BEFORE WORKING ON OR IN TANKS WHICH CONTAIN OR HAVE CONTAINED THIS
CLEANING, WELDING, REPAIRING OR OTHER CONTEMPLATED OPERATIONS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:VM&P NAPHTHA
Other REC Limits:NONE RECOMMENDED
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION, SKIN ABSORPTION OR
INGESTION MAY CAUSE CENTRAL NERVOUS SYTEM DEPRESSION. INHALATION
MAY ALSO CAUSE RESPIRATORY IRRITATION. SKIN OR EYE CONTACT MAY
CAUSE IRRITATION. ASPIRATION MAY C AUSE LUNG INFLAMMATION/DAMAGE.
CHRONIC:PROLONGED OR REPEATED EXPOSURE AMY CAUSE DERMATITIS,
LIVER/KIDNEY DAMAGE.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GRETAER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED/INGESTED/SKIN ABSORPTION: DIZZINESS,
SHORTNESS OF BREATH, HEADACHE, NAUSEA, WEAKNESS, VOMITING. EYES:
SWELLING, REDNESS, TEARING, DISCOMFORT, BURNING SENSATION. SKIN:
REDNESS, ITCHING, BURNING SENSATION.
Medical Cond Aggravated by Exposure:LUNG DISORDERS, SKIN DISOREDERS
* First Aid Measures *
First Aid:INHALED:REMOVE TO FRESH AIR.GIVE ARTIFICIAL RESPIRATION IF
BREATHING STOPPED.GIVE OXYGEN IF BREATHING DIFFICULT.SEEK MEDICAL
OPEN.SEEK MEDIC AL HELP.SKIN:REMOVE CONTAMINATED CLOTHES.WASH WITH
SOAP AND WATER.IF IRRITATION DEVELOPS,SEE DOCTOR.INGESTED:IF
CONSCIOUS,INDUCE VOMITING WITH SYRUP OF IPECAC.GET IMMEDIATE
MEDICAL HELP.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.9%
Upper Limits:7.0%
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL. WATER MAY BE
INEFFECTIVE ON THIS MATERIAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE CLOTHING. USE WATER SPRAY TO MINIMIZE VAPORS AND TO
COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:MATERIAL IS FLAMMABLE AND MAY BE IGNITED
BY HEAT, SPARKS, FLAME OR STATIC ELECTRICITY.
* Accidental Release Measures *
Spill Release Procedures:STAY UPWIND AND AWAY FROM SPILL. ELIMINATE ALL
SOURCES OF IGNITION. SUPRESS VAPORS WITH FOAM. KEEP OUT OF DRAINS,
SEWERS, WATERWAYS. USE SAND OR OTHER INERT MATERIAL TO DIKE AND
CONTAIN SPILL. DO NOT FLUSH SPILL. ABSORB WITH INERT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, STRONG ALKALIS AND
AMINES. STORE AWAY FROM SOURCES OF IGNITION.
Other Precautions:DO NOT CUT, WELD, OR DRILL EMPTY CONTAINER; IT MAY
CONTAIN RESIDUE WHICH MAY EXPLODE OR IGNITE. PROPERLY BOND AND
GROUND ALL CONTAINERS DURING TRANSFER OPERATIONS.
* Physical/Chemical Properties *
HCC:F3
Vapor Density:3.9(AIR=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR AMBER LIQUID; AROMATIC ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, STRONG ALKALIS AND
SELECTED AMINES.
Stability Condition to Avoid:HIGH TMPERATURE STORAGE. CONTACT WITH
STRONG OXIDIZING AGENTS, STRONG OXIDIZING AGENTS, STRONG ALKALIS,
SOME AMINES.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
| 1 | gloves_mandatory |
Subsets and Splits
No saved queries yet
Save your SQL queries to embed, download, and access them later. Queries will appear here once saved.