text
stringlengths 307
13.1k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED SCBA OR AIR RESPIRATOR OR
AIR MASK WHERE THERE IS OXYGEN DEFICIENCY.
Ventilation:LOCAL EXHAUST:EXPLOSION PROOF TYPE.
Other Protective Equipment:ALL MOTORS & SWITCHES SHOULD BE EXPLOSION
PROOF.
Work Hygienic Practices:N/K
Supplemental Safety and Health
N/K
* Product Identification *
Product ID:FLAME CONTROL VARNISH
CAGE:FLAMC
CAGE:FLAMC
* Composition/Information on Ingredients *
Ingred Name:ANTIMONY PENTOXIDE; (ANTIMONY OXIDE)
Fraction by Wt: 1%
OSHA PEL:0.5 MG/M3 (SB)
ACGIH TLV:0.5 MG/M3 (SB)
Ingred Name:MINERAL SPIRITS; (STODDARD SOLVENT). VP:2. LEL:1.1%.
Fraction by Wt: SEE ING
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:REPORTS HAVE ASSOCIATED REPEATED &
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE.INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE VAPORS M AY BE HARMFUL OR FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:IRRITATION. SKIN:DEFATTING, SLIGHT
IRRITANT.
Medical Cond Aggravated by Exposure:PRE-EXISTING UPPER RESPIRATORY &
LUNG DISEASE SUCH AS, BUT NOT LIMITED TO, BRONCHITIS, EMPHYSEMA,
ASTHMA.
* First Aid Measures *
MINUTES.SEE MD.SKIN:REMOVE FROM FURTHER EXPOSURE,FLUSH AFFECTED
AREA WITH WATER OR MILD SOAP AND WATER.INGESTION:CALL MD
IMMEDIATELY .INHAL ATION:REMOVE TO FRESH AIR.SUPPORT BREATHING
(GIVE O*2/ARTIFICIAL RESPIRATION) .
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:SEE ING 2
Upper Limits:0.7%
Extinguishing Media:FOAM,CARBON DIOXIDE,DRY CHEMICAL
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .WATER NOT ORDINARILY EFFECTIVE,SOLID HOSE
STREAMS TEND TO SPREAD FIRE.
Unusual Fire/Explosion Hazard:THIS MATERIAL IS COMBUSTIBLE & MAY BE
IGNITED BY HEAT, SPARKS, FLAME & STATIC ELECTRICITY.
* Accidental Release Measures *
Spill Release Procedures:WIPE UP IMMEDIATELY AND DISCARD SATURATED
ABSORBENTS.IN EVENT OF LARGE SPILLS,DIKE AREA AND PUMP MATERIAL
INTO WASTE TANK,REMOVE ANY SOURCE OF IGNITION,AVOID BREATHING OF
VAPORS.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:MATL IS CLASSIFIED AS A COMBUST LIQ.
KEEP AWAY FROM HEAT & OPEN FLAME. USE W/ADEQ VENT. AVOID CONTACT
Other Precautions:AVOID SKIN CONTACT & BREATHING OF VAPORS & SANDING
DUST. USE W/ADEQUATE VENTILATION.
* Physical/Chemical Properties *
HCC:F4
Melt/Freeze Pt:M.P/F.P Text:
Decomp Temp:Decomp Text:
Vapor Pres:
Vapor Density:>1 (AIR=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:6.7
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS/BASES, OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION IN THE PRESENCE
OF AIR MAY YIELD CARBON MONOXIDE AND/OR CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHERE ADEQ VENT CNDTNS EXIST. IF
AIRBORNE CONC IS HIGH, A NIOSH/MSHA APPRVD CHEM CARTRIDGE RESP
W/ORGANIC VAP CARTIDGE IS REC. IF CONCS EXCEED CAPACITY OF
CARTRIDGE RESP, A NIOSH/MSHA AP PRVD SCBA IS ADVISED.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS. VENT HOOD.
Other Protective Equipment:UNIFORM & APRON ARE RECOMMENDED. LAB COAT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
OTHER PREC:OR PHOSGENE .
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ETHANE, 1,1,1-TRICHLORO-; (1,1,1-TRICHLOROETHANE)
Ozone Depleting Chemical:1
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:MAY CAUSE PULMONARY EDEMA,
HEADACHE, NAUSEA, VOMITING, DIZZINESS, DROWSINESS, IRRITATION OF
UPPER RESPIRATORY TRACT, UNCONSCIOUSNESS. SKIN CONTACT:IRRITATION,
PROLONGED CONTACT MAY CAUSE D ERMATITIS. EYE CONTACT:IRRITATION.
INGEST:NAUSEA, VOMITING. CHRONIC: KIDNEY/LIVER DAMAGE. (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:TARGET ORGANS:CNS, SKIN, EYES, CVS.
CHLOROCARBON MATLS HAVE PRDCD SENSIT OF MYOCARDIUM TO EPINEPHRINE
IN LAB ANIMALS & COULD HAVE SIMILAR EFT IN HUMANS. ADRENOMIMETICS
(E.G., EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR
LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY EXPOS TO
CHLOROCARBONS .
Medical Cond Aggravated by Exposure:LIVER DISORDERS, HEART DISORDERS,
SENSITIVE SKIN.
* First Aid Measures *
First Aid:INGEST:CALL MD. IF SWALLOWED, DO NOT INDUCE VOMITING.
INHAL:REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. SKIN:FLUSH
MINUTES.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:7.5%
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA &
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE HCL & PHOSGENE .
* Accidental Release Measures *
Spill Release Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT CLTHG.
STOP LEAK IF YOU CAN DO SO W/OUT RISK. USE WATER SPRAY TO REDUCE
VAPORS. TAKE UP W/SAND OR OTHER NON-COMBUST ABSORB MATL & PLACE
INTO CNTNR FOR LATER DIS POSAL. FLUSH SPILL AREA W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CNTNR TIGHTLY CLSD. SUITABLE FOR
ANY GEN CHEM STOR AREA. HARMFUL - STOW AWAY FROM FOOD STUFFS.
CAUSES IRRIT. HARMFUL IF SWALLOWED/INHALED.
Other Precautions:AVOID CONT W/EYES, SKIN, CLTHG. AVOID BRTHG VAP. USE
W/ADEQ VENT. KEEP OUT OF REACH OF CHILDREN. NO SMOKING IN AREA OF
USE. DO NOT USE IN GEN VICIN OF ARC WELDING, OPEN FLAMES/HOT SURFS.
HEAT &/OR UV RADIA MAY CAUSE FORM OF HCL &/ (SUPDAT)
* Physical/Chemical Properties *
Vapor Density:4.6
Solubility in Water:NEGLIGIBLE (<0.1%)
Appearance and Odor:COLORLESS LIQUID; FAINT ETHER-LIKE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, STRONG BASES, ALUMINUM, CHEMICALLY ACTIVE METALS, STRONG
OXIDIZING AGENTS.
Stability Condition to Avoid:MOISTURE, INSUFFICIENT INHIBITOR, HEAT,
FLAME, OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:HYDROGEN CHLORIDE, PHOSGENE, CHLORINE,
CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE I/A/W ALL APPLICABLE FEDERAL, STATE &
(TOXIC WASTE).
| 1 | gloves_mandatory |
Control Measures
*
Cage: 0FTT5
*
Preparer Co. when other than Responsible Party Co.
*
Cage: 0FTT5
*
Contractor Summary
*
Cage: 0FTT5
*
Item Description Information
*
Item Manager: GSA
Item Name: ENAMEL
Unit of Issue: PT
UI Container Qty: 0
*
Ingredients
*
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 5 PPM
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE RECOMMENDED
------------------------------
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Other REC Limits: NONE RECOMMENDED
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL: HARMFUL, FATAL, BRAIN/NS DAMAGE, HEADACHE,
ANESTHETIC, RESPIRATORY TRACT IRRITATION, LIGHT HEADEDNESS, STAGGERING GAIT,
GIDDINESS, NAUSEA. SKIN: IRRITATION. INGEST: HARMFUL. EYE: IRRITATION.
Medical Cond Aggravated By Exposure: RESPIRATORY AILMENTS.
First Aid: SKIN: WASH WITH SOAP AND WATER. WASH CLOTHES BEFORE REUSE. EYE:
VOMIT. GET MEDICAL ATTENTION. INHAL: GET FRESH AIR. ARTIFICI AL RESPIRATION
IF NEEDED. GET MEDICAL ATTENTION.
*
Handling and Disposal
*
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION AND VENTILATE AREA.
MOP SPILLS WITH INERT ABSORBENT. AVOID BREATHING VAPORS.
Waste Disposal Methods: DISPOSE IN ACCORD WITH FEDERAL, STATE, LOCAL
HEAT/PROLONGED EXPOSURE TO SUN MAY CAUSE CAN TO BURST. DISCARD EMPTY CAN IN
TRASH PICK- UP. DONT PLACE IN HOME TRASH COMPACTOR.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. CONTENTS UNDER
Other Precautions: USE WITH GOOD VENTILATION. READ ENTIRE LABEL BEFORE USING.
FOLLOW ALL LABEL DIRECTIONS. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING
AND INHALING OR SWALLOWING CONTENTS MAY BE HARMFUL OR FATAL.
*
Fire and Explosion Hazard Information
*
Lower Limits: 2.2
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY.
AVOID SPREADING ANY BURNING LIQUID WITH WATER SPRAY.
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE. USE WATER TO COOL
CONTAINER. WEAR SCBA. USE SHIELDING TO PROTECT PERSONNEL AGAINST BURSTING,
RUPTURING OR VENTING OF CONTAINER.
Unusual Fire/Explosion Hazard: DONT SPRAY NEAR OPEN FLAME. AT ELEVATED
*
*
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
Ventilation: LOCAL EXHAUST PREFERRED. MECHANICAL (GENERAL): ACCEPTABLE AT POINT
OF MIST OR SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN. EYE WASH
STATION.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DONT EAT, DRINK, OR SMOKE
WHILE USING PRODUCT.
*
Physical/Chemical Properties
*
B.P. Text: NA
M.P/F.P Text: NA
Decomp Text: NA
PH: NA
Viscosity: NA
Solubility in Water: INSOLUBLE
Appearance and Odor: OLIVE DRAB, PAINT.
Corrosion Rate: NA
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT.
Materials To Avoid: NA
Hazardous Decomposition Products: CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NA
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: PT
Container QTY: 0
*
Detail DOT Information
*
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Bulk Pack: NONE
Vessel Stow Req: A
*
Detail IMO Information
*
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
*
Detail IATA Information
*
IATA PSN Code: ALS
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
*
Detail AFI Information
*
AFI PSN Code: ALR
AFI Symbols: *
AFI Proper Shipping Name: AEROSOLS, FLAMMABLE, N.O.S.
AFI PSN Modifier: (EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.1
Special Provisions: P4
Back Pack Reference: A6.3
*
HAZCOM Label
*
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Label Required IND: Y
Status Code: A
Origination Code: G
Hazard And Precautions: INHAL: HARMFUL, FATAL, BRAIN/NS DAMAGE, HEADACHE,
ANESTHETIC, RESPIRATORY TRACT IRRITATION, LIGHT HEADEDNESS, STAGGERING GAIT,
GIDDINESS, NAUSEA. SKIN: IRRITATION. INGEST: HARMFUL. EYE: IRRITATION.
*
| 1 | gloves_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Item Description Information
*
Item Manager: GSA
Item Name: THINNER,PAINT PRODUCTS
Type/Grade/Class: TYPE 2
Unit of Issue: GL
UI Container Qty: 6
Type of Container: METAL
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Effects of Exposure: EYE CONTACT: SLIGTHLY IRRITATING BUT DOES NOT INJURE EYE
TISSUE. SKIN CONTACT: LOW ORDER OF TOXICITY.FREQUENT OR PROLONGED CONTACT
MAY IRRITATE AND CAUSE DERMATITIS. INHALATION: HIGH VAPOR/AEROSOL
EYES AND THE RESPIRATORY TRACT, MAY CAUSE HEADACHES, DIZZINESS, ANESTHESIA,
DROWSINESS, UNCONSCIOUSNESS, AND OTHER CENTRAL N ERVOUS SYSTEM EFFECTS,
INCLUDING DEATH. INGESTION: SMALL AMOUNTS OF THIS PRODUCT ASPIRATED INTO THE
RESPIRATORY SYSTEM DURING INGESTION OR VOMITING MAY CAUSE MILD TO SEVERE
PULMONARY INJURY, POSSIBLY PROGRESSING TO DEATH.
First Aid: FLUSH EYES WITH LARGE AMOUNTS OF WATER UNTIL IRRITATION SUBSIDES.
IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. SKIN CONTACT: FLUSH WITH LARGE
AMOUNTS OF WATER; USE SOAP IF AVAILABLE. INHALATION: US ING PROPER
RESPIRATORY PROTECTION, IMMEDIATELY REMOVE THE AFFCTED VICTIM FROM
EXPOSURE. INGESTION: DO NOT INDUCE VOMITING. KEEP AT REST. GET MEDICAL
ATTENTION.
*
Handling and Disposal
*
Handling And Storage Precautions: KEEP CONTAINER CLOSED. HANDLE AND OPEN
CONTAINERS WITH CARE. STORE IN A COOL, WELL VENTILATED PLACE AWAY FROM
INCOMPATIBLE MATERIALS.
*
Fire and Explosion Hazard Information
*
Flash Point Method: TCC
Lower Limits: 1.4
Upper Limits: 9.3
Extinguishing Media: USE FOAM, DRY CHEMICAL, OR WATER SPRAY TO EXTINGUISH FIRE.
Fire Fighting Procedures: USE WATER SPRAY TO COOL FIRE EXPOSED SURFACES AND TO
PROTECT PERSONNEL. ISOLATE "FUEL" SUPPLY FROM FIRE.
Unusual Fire/Explosion Hazard: THIS LIQUID IS VOLATILE AND GIVES OFF INVISIBLE
VAPORS. EITHER THE LIQUID OR VAPOR MAY SETTLE IN LOW AREAS OR TRAVEL SOME
DISTANCE ALONG THE GROUND OR SURFACE TO IGNITION SOURCES WHERE THEY MAY
IGNITE OR EXPLODE.
*
*
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATORS MAY BE NECESSARY TO
PREVENT OVEREXPOSURE BY INHALATION.
Ventilation: THE USE OF LOCAL EXHAUST VENTILATION IS RECOMMENDED.
*
Physical/Chemical Properties
*
Decomp Text: NONE
Vapor Pres: MMHG AT DEG F
Evaporation Rate & Reference: N-BUTYL ACETATE=1: 0.1
*
Reactivity Data
*
Stability Indicator: YES
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
*
Toxicological Information
*
Toxicological Information: PLEASE REFER TO SECTION 3 FOR AVAILABLE INFORMATION
ON POTENTIAL HEALTH EFFECTS.
*
Ecological Information
*
*
HAZCOM Label
*
Assigned IND: Y
Company Name: EXXONMOBIL CHEMICAL COMPANY A DIVISION OF EXXON MOBIL CORP.
Label Required IND: Y
Status Code: A
Origination Code: G
Hazard And Precautions: EYE CONTACT: SLIGTHLY IRRITATING BUT DOES NOT INJURE
EYE TISSUE. SKIN CONTACT: LOW ORDER OF TOXICITY.FREQUENT OR PROLONGED
CONTACT MAY IRRITATE AND CAUSE DERMATITIS. INHALATION: HIGH VAPOR/AEROSOL
EYES AND THE RESPIRATORY TRACT, MAY CAUSE HEADACHES, DIZZINESS, ANESTHESIA,
DROWSINESS, UNCONSCIOUSNESS, AND OTHER CENTRAL N ERVOUS SYSTEM EFFECTS,
INCLUDING DEATH. INGESTION: SMALL AMOUNTS OF THIS PRODUCT ASPIRATED INTO THE
RESPIRATORY SYSTEM DURING INGESTION OR VOMITING MAY CAUSE MILD TO SEVERE
PULMONARY INJURY, POSSIBLY PROGRESSING TO DEATH.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VAPOR CONCENTRATION EXCEEDS TLV, USE
RESPIRATOR APPROVED BY U.S. BUREAU OF MINES FOR ORGANIC VAPORS.
Ventilation:ADEQUATE VENTILATION TO KEEP BELOW TLV
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE HANDLING FOOD.
REMOVE CONTAMINATED CLOTHING.
Supplemental Safety and Health
* Product Identification *
Product ID:MISTY FURNITURE POLISH
* Composition/Information on Ingredients *
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
Ingred Name:PROPANE
ACGIH TLV:SIMPLE ASPHYXIANT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXCESSIVE INHALATION OF VAPORS CAN BE
HARMFUL. ANESTHETIC EFFECTS & POSSIBLE UNCONSCIOUSNESS. EYES/SKIN:
IRRITATION. INGESTION: POSSIBLE CHEMICAL PNEUMONITIS IF ASPIRATED
INTO LUNGS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, DIZZINESS, ASPHYXIA,
ANESTHETIC EFFECTS. INGESTION: NAUSEA.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN OR UPPER
RESPIRATORY CONDITIONS.
* First Aid Measures *
INHALATION: REMOVE TO FRESH AIR. RESUSCITATE IF NECESSARY.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Extinguishing Media:FOAM, DRY CHEMICAL, CO2, WATER FOG
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS
Unusual Fire/Explosion Hazard:DON'T EXPOSE AEROSOLS TO TEMPERATURES
* Accidental Release Measures *
Spill Release Procedures:ABSORB W/SUITABLE MEDIUM. DON'T FLUSH TO
SEWER.
*Handling and Storage *
Handling and Storage Precautions:DON'T PUNCTURE OR INCINERATE
SOURCES.
Other Precautions:AVOID FOOD CONTAMINATION. KEEP OUT OF REACH OF
CHILDREN. AVOID BREATHING VAPORS.
* Physical/Chemical Properties *
Solubility in Water:PARTIAL
Appearance and Odor:CREAM COLOR, LEMON FRAGRANCE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:OPEN FLAME, WELDING ARCS, HEAT, SPARKS,
Hazardous Decomposition Products:CO, CO2
* Disposal Considerations *
Waste Disposal Methods:INCINERATE OR LANDFILL ACCORDING TO LOCAL,
STATE, OR FEDERAL REGULATIONS. AEROSOL CANS WHEN VENTED TO
ATMOSPHERIC PRESSURE THROUGH NORMAL USE, POSE NO DISPOSAL HAZARD.
| 1 | gloves_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
Cage: 0A6H9
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EXPOS FROM THIS ALKALINE MIX MAY RSLT IN REDDENING
OF SKIN, MOD IRRIT & POSS DISCOMFORT. IRRIT BY INHAL & BY MIST TO
UPPER RESP TRACT/OTHER MUC MEMB AREAS. EYE CONT PRODUCES TEARING, IRRIT &
DI SCOMFORT. ACCIDENTAL INGEST MAY CAUSE NAUS, DIARR & IRRIT OF
INTESTINAL LINING. CHRONIC: LONG TERM (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: MISUSE RSLTG FROM AIRBORNE CONCS
OF MIST/SPRAY MAY CAUSE DMG TO UPPER RESP TRACT. CHRONIC EFTS MAY RSLT IN
SUPERFICIAL DESTRUCTION OF SKIN TISS & DERM. CHRONIC EYE EXPOS CAN LEAD
TO DESTRUCT ION OF EYE TISS TO BLINDNESS. TARGET ORGANS INCL: LIVER, KIDNEY,
LYMPHOID SYS, SKIN, BLOOD, EYES, RESP SYS. (SUP DAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: TYPICALLY NOT A HAZ, BUT GET TO FRESH AIR & TREAT
SYMPTOMATICALLY. EYE: OBJECT IS TO SEEK MED ATTN IMMED. IMMED FLUSH W/PLENTY
ENTIRE EYE SURF. SEEK MED ATTN IF ANY IRRIT PERSISTS. SKIN: WASH W/PLENTY OF
WATER. SEEK MED ATTN IF ANY IRRIT PERSISTS. INGEST: DO NOT INDUCE VOMIT. GIVE
GLASS OF MILK/WATER & CALL
*
Handling and Disposal
*
Spill Release Procedures: AEROSOL PACKAGING, SO SPILL UNLIKELY. IF LEAK OCCURS,
WIPE UP RESIDUE AND FLUSH AREA WITH WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS CONCERNING HEALTH AND POLLUTION. DO NOT PUNCTURE OR INCINERATE
CANS.
BEFORE USING.
Other Precautions: KEEP OUT OF REACH OF CHILDREN. WARNING: THIS PRODUCT
CONTAINS THE FOLLOWING CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER/BIRTH DEFECTS/OTHER REPRODUCTIVE HARM: DIOXANE AND FORMALDEHYDE A S
*
Fire and Explosion Hazard Information
*
Flash Point Text: NON-FLAMMABLE
Extinguishing Media: USE FOAM, "ALCOHOL" FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER SPRAY.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). USE WATER SPRAY TO COOL EXPOSED CONTAINERS TO AVOID
BURSTING.
Unusual Fire/Explosion Hazard: DO NOT PUNCTURE OR INCINERATE AEROSOL CANS.
*
*
Respiratory Protection: USE OF PRODUCT DOES NOT REQUIRE THE USE OF A
RESPIRATOR. DUE TO AEROSOL PACKAGING, EMERGENCY SITUATION IS ALMOST
IMPOSSIBLE. USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN (FP N).
Ventilation: GOOD INDUS HYGIENE PRACT DICTATES THAT WORK AREAS SHOULD PROVIDE
ADEQ VENT/CTLS TO MAINTAIN & MEET OSHA REQUIREMENTS.
Other Protective Equipment: EMERGENCY EYEWASH & DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: USERS OF "L" VERSION TO CONSULT "LR" VERSION
FOR ADDNL INFO (FP N). EFTS OF OVEREXP: LIVER & KIDNEY DMG COULD OCCUR
W/LONG TERM MASSIVE EXPOS BECAUSE OF ABNORMAL BLOOD PRODUCTION. ANIMAL
STUDIES CLEAR LY DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON CNS, HEMATOPOIETIC
TISS, BLOOD, KIDNEYS & LIVER, ASSOC W/ADMIN OF
*
Physical/Chemical Properties
*
Vapor Density: 0.6
Evaporation Rate & Reference: 0.1 (BUTYL ACETATE=1)
Solubility in Water: COMPLETE
Appearance and Odor: OPAQUE WHITE FOAM, WITH PLEASANT ODOR
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: OXIDES OF CARBON.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: NCH CORP
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EXPOS FROM THIS ALKALINE MIXTURE MAY RESULT IN
REDDENING OF SKIN, MOD IRRIT & POSS DISCOMFORT. IRRITATING BY INHAL &
BY MIST TO UPPER RESP TRACT/OTHER MUCOUS MEMBRANE AREAS, EYE CONT PRODUCES T
EARING, IRRIT & DISCOMFORT. ACCIDENTAL INGEST MAY CAUSE NAUS, DIARRHEA
& IRRIT OF INTESTINAL LINING. CHRONIC: LONG TERM MISUSE MAY DAMAGE UPPER
RESP TRACT. CHRONIC EFTS MAY RESULT IN SUPERFICIAL DESTR UCTION OF SKIN
TISSUE & DERM. CHRONIC EYE EXPOS CAN CAUSE DESTRUCTION & BLINDNESS.
ANIMAL STUDIES HAVE DEMONSTRATED DOSE-RELATED ADVERSE EFTS TO CNS,
BLOOD-FORMING TISSUE, BLOOD, LIVER & KIDNEYS, ASSO CIATED
W/ADMINISTRATION OF 2-BUTOXYETHANOL (FP N).
*
| 1 | gloves_mandatory |
Control Measures
*
Kit Part: Y
Proprietary Ind: Y
*
Contractor Summary
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EXPOSURE TO THE EYE CAUSES MINOR SUPERFICIAL AND TRANSIENT
EFFECTS.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
MINUTES & GET MEDICAL ATTENTION. SKIN: IMMEDIATELY REMOVE CONTAMINATED CL
OTHING. WASH AFFECTED AREAS WITH SOAP AND WATER. WASH CONTAMINATED CLOTHING
BEFORE REUSE. INGEST: GIVE MILK OR EGG WHITE BEATEN W/WATER UNTIL VOMIT FLUID
IS CLEAR. REPEAT MILK OR WHITE OF EGG (SUPDAT)
*
Handling and Disposal
*
Spill Release Procedures: PHYSICALLY RECOVER FREE LIQUID AND THEN CLEAN UP WITH
ABSORBENT MATERIAL AND WASH AREA WITH WATER AND DETERGENT.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: THIS PRODUCT SHOULD BE CLASSIFIED AS NON-HAZARDOUS FOR
PURPOSES OF DISPOSAL; IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: STORE IN COOL, DRY AREA. GOOD INDUSTRIAL
PRACTICE AS TO HOUSEKEEPING, PERSONAL HYGIENE & AVOIDANCE OF PRLNGD SKIN
OR EYE CONTACT SHOULD BE OBSERVED.
Other Precautions: KEEP CONTAINER CLOSED WHEN NOT IN USE. STORE DRUM UPRIGHT TO
*
Fire and Explosion Hazard Information
*
Flash Point Method: TCC
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, WATER SPRAY, FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N). AVOID EYE AND SKIN CONTACT; DO NOT BREATHE FUMES.
Unusual Fire/Explosion Hazard: NONE.
*
*
Respiratory Protection: NOT REQUIRED NOR NORMALLY NEEDED. USE NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: LOCAL EXHAUST: NORMAL GOOD PRACTICE. MECHANICAL: NORMAL GOOD
PRACTICE.
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N). ANY
BOOTS.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: FIRST AID PROC: BEATEN W/WATER. IF VOMITING
DOES NOT OCCUR, INDUCE VOMITING BY GAGGING VICTIM W/FINGER OR BLUNT OBJECT
PLACED ON BACK OF VICTIM'S TONGUE. DO NOT INDUCE VOMITING OR GIVE ANYTHING BY
MOU TH TO UNCONSCIOUS PERSON. CALL MD IMMEDIATELY.
*
Physical/Chemical Properties
*
Vapor Density: 8
Evaporation Rate & Reference: NEGLIG (BUTYL ACETATE=1)
Solubility in Water: NO
Appearance and Odor: AMBER LIQUID, CLEAR OR PIGMENTED COLOR; MUSTY ODOR.
Percent Volatiles by Volume: NIL
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: CONTACT WITH STRONG BASES. EXCESSIVE HEAT AND/OR
OPEN FLAME.
Materials To Avoid: MILD STEEL, COPPER.
Hazardous Decomposition Products: BURNING MAY PRODUCE IRRITATING AND TOXIC
FUMES (IE, CARBON MONOXIDE).
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: TECHNICAL URETHANES INC
Street: UNKNOWN
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: EXPOSURE TO THE EYE CAUSES MINOR
SUPERFICIAL AND TRANSIENT EFFECTS. CHRONIC: NONE LISTED BY MANUFACTURER.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:COIN TYPE LITHIUM BATTERIES CR
* Composition/Information on Ingredients *
Ingred Name:LITHIUM; (LITHIUM METAL)
Fraction by Wt: 1-3%
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NOT RELEVANT
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:WASH OUT W/WATER
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL OR DRY SAND.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:IN THE ABNORMAL CASE, EXAMPLE: CHARGE TO
HIGHER THAN 5 VOLTS AT HIGH AMPERAGE, THE TOP MAY POP UP.
* Accidental Release Measures *
Spill Release Procedures:IF BATTERY IS ACCIDENTLY BROKEN & ORGANIC
ELECTROLYTE (PROPYLENE CARBONATE D.M.E. & LI CLO*4 AS A SOLUTE)
LEAKS OUT, WIPE IT UP W/CLOTH & DISPOSE OF IT IN A PLASTIC BAG &
PUT INTO A STEEL CAN.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:DO NOT RECHARGE, DISASSEMBLE, HEAT
Other Precautions:
* Physical/Chemical Properties *
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . IT IS REC TO DISCHARGE BATTERY TO END, TO USE UP
METAL LITHIUM INSIDE BATTERY & TO BURY DISCHARGED BATTERY IN SOIL.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED.
ROOM VOLUMES/HOUR.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER, WASHING
FACILITIES.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
THIS MSDS REPRESENTS THE WORKING SOLUTION OF A KODAK KIT.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM CARBONATE
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHANOL, 2,2',2"-NITRILOTRI-; (TRIETHANOLAMINE)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 MG/M3
Ingred Name:N,N-DIETHYLHYDROXYLAMINE
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-
METHYLPHENYLENEDIAMINESESQUISULFATE MONOHYDRATE
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE LOW HAZARD FOR
RECOMMENDED HANDLING FOR INHALATION. CONTACT MAY CAUSE TRANSIENT
EYE IRRITATION; SKIN IRRITATION, MAY CAUSE ALLERGIC SKIN REACTION.
INGESTION MAY CAUSE GI TRACT IRRITATIO N. CHRONIC: NONE SPECIFIED
BY MANUFACTURER.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYES: MAY CAUSE IRRITATION. SKIN: MAY CAUSE
SKIN IRRITATION. MAY CAUSE AN ALLERGIC REACTION. INGESTION: MAY
CAUSE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALED-REMOVE TO FRESH AIR & TREAT SYMPTOMATICALLY.
SYMPTOM OCCUR. SKIN-REMOVE CONTAMINATED CLOTHES. WASH WITH SOAP &
WATER. GET MEDICALATTENTION IF SYMPTOMS OCCUR. INGESTED-IF
CONSCIOUS, DRINK 1-2 GLASSES WATER. SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
FLUSH TO SEWER WITH LOTS OF WATER OR ABSORB WITH INERT MATERIAL AND
PLACE IN A CHEMICAL WASTE CONTAINER. CLEAN SURFACE THOROUGHLY TO
REMOVE RESIDUAL CONTA MINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. AVOID
CONTACT WITH EYES AND AVOID CONTACT WITH SKIN & CLOTHES. KEEP
CONTAINER CLOSED.
Other Precautions:ROUTINE USE OF A NONALKALINE HAND CLEANSER MAY HELP
MINIMIZE SKIN REACTION.
* Physical/Chemical Properties *
HCC:B3
Vapor Density:0.6
Evaporation Rate & Reference:N/K (N-BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, LIGHT YELLOW SOLUTION; SLIGHT AMINE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Other Protective Equipment:USE TONGS & OTHER DEVICES FOR HANDLING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:LITHIUM
Ingred Name:THIONYL CHLORIDE
Other REC Limits:1 PPM
OSHA PEL:1 PPM
ACGIH TLV:C 4.9 MG/CUM
Ingred Name:LITHIUM ALUMINUM CHLORIDE; LITHIUM TETRACHLOROALUMINATE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IN PRESENCE OF MOISTURE,
PULMONARY EDEMA & LARYNGEAL SPASM CAN OCCUR. SEVERE IRRITATION OF
NOSE & THROAT, BURNS TO MUCOUS MEMBRANES. EYES: BURNS & IRRITATION.
SKIN: BURNS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: IN CONFINED SPACE CAN LEAD TO
ASPHYXIATION.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN/EYES: FLUSH W/LARGE
IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:SAND, DRY CHEMICAL, FOAM, METAL-X
Fire Fighting Procedures:REMOVE OTHER BATTERIES & POTENTIAL COMBUSTIBLE
MATERIALS FROM AREA OF BURNING BATTERY & CONTAIN & EXTINGUISH
W/AGENTS LISTED ABOVE.
LEAD TO MELTING OF LITHIUM & IS FIRE/EXPLOSION HAZARD.
* Accidental Release Measures *
Spill Release Procedures:IF CELL VENTS OR IS PUNCTURED, VENTILATE AREA
WELL. COVER ANY LIQUID RESIDUE W/SODIUM BICARBONATE. SCOOP
RESULTING RESIDUE INTO PLASTIC BAG OR FIBER DRUM. THE REMAINS CAN
THEN BE FLUSHED W/LARGE AMOUN TS OF WATER. WEAR PROTECTIVE
EQUIPMENT.
Neutralizing Agent:SODIUM BICARBONATE
*Handling and Storage *
Handling and Storage Precautions:DON'T PUNCTURE/INCINERATE/SHORT
NEVER STORE IN LOOSE BINS. DON'T CHARGE.
Other Precautions:DON'T USE CELLS IN HERMETICALLY SEALED CONTAINERS.
DON'T EXPOSE CELLS TO CHARGING CURRENTS. NEVER CUT INTO CELL. DON'T
EXPOSE VENTED CELLS TO WATER. STORE IN COOL, WELL-VENTILATED AREA.
USE FUSES/LIMI TING RESISTORS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, METAL SURFACES
Hazardous Decomposition Products:HYDROGEN CHLORIDE & SULFUR DIOXIDE
* Disposal Considerations *
Waste Disposal Methods:DISCHARGED CELLS MAY CONTAIN SIGNIFICANT AMOUNTS
OF ENERGY SO HANDLE W/CARE. THEY SHOULD BE ELECTRICALLY
ISOLATED/PACKED FOR DISPOSAL. DON'T COMPACT. DISPOSE OF IN SANITARY
LANDFILLS ACCORDING TO LOCA L/STATE/FEDERAL REG. DON'T DISPOSE OF
IN FIRE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:LOCAL EXHAUST: USUALLY ADEQUATE
Supplemental Safety and Health
* Product Identification *
Product ID:NEW PUNCH
* Composition/Information on Ingredients *
Ingred Name:AROMATIC POLYOXYALKALENE
Ingred Name:SODIUM PHOSPHATE, TRIBASIC(SARA III)
Other REC Limits:5 MG/M3
Ingred Name:SILICATES
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION.
* First Aid Measures *
SEE PHYSICIAN. SKIN: WASH W/WATER & APPLY LANOLIN. INGESTION: GIVE
COPIOUS AMOUNTS OF WATER. SEE PHYSICIAN.
* Fire Fighting Measures *
Flash Point:NONE
* Accidental Release Measures *
Spill Release Procedures:MOP UP OR FLUSH DOWN FLOOR DRAIN.
*Handling and Storage *
Handling and Storage Precautions:FOLLOW LABEL DIRECTIONS. KEEP OUT OF
EYES. KEEP OUT OF REACH OF CHILDREN.
* Physical/Chemical Properties *
Vapor Density:0.6
Evaporation Rate & Reference:(WATER = 1): 0.1
Solubility in Water:SOLUBLE
Appearance and Odor:FLORESCENT LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:MAY BE DISPOSED OF IN A SEWER DRAIN.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO ENTRAIN ALL PARTICULATE
EMISSIONS. HEPA FILTER REQUIRED. NO LEAKS ON PRESSURE SIDE OF FAN.
Other Protective Equipment:USE COVERALLS OR DISPOSABLE CLOTHING.
Work Hygienic Practices:WET WORK TO THE DEGREE POSSIBLE. WASH HANDS
AFTER HANDLING GASKET. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
MSDS GENERATED BY HMIS TECHNICIAN. MANUFACTURER IS UNKNOWN OR OUT OF
BUSINESS.
* Product Identification *
Preparer's Name:HMIS TECHNICIAN
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
Ingred Name:BUTADIENE/ACRYLONITRILE RUBBER
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:MINOR EYS/SKIN IRRITATION.
INGESTION- IRRITATION OF GI TRACT. INHALATION-IRRITATION OF
RESPIRATORY TRACT. CHRONIC: ASBESTOSIS, LUNG CANCER, &
MESOTHELIOMA, ALL OF WHICH ARE DISABLING AND FATAL D ISEASES OF THE
LUNG. INHALATION AND INGESTION OF ASBESTOS FIBERS MAY CAUSE CANCER
OF THE BOWEL.
Explanation of Carcinogenicity:ASBESTOS IS A KNOWN HUMAN CARCINOGEN.
Effects of Overexposure:INHALATION: FATIGUE AND SHORTNESS OF BREATH
THAT GETS WORSE WITH TIME AND EVENTUALLY BECOMES DISABLING. EYES:
IRRITATION. SKIN: IRRITATION. INGESTION: MILD STOMACH DISTRESS.
DIARRHEA, VOMITING, AND NA USEA.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND TUBERCULOSIS
ARE ALL GENERALLY AGGRAVATED BY EXPOSURE TO ASBESTOS FIBERS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. SEE DOCTOR. EYES: RINSE
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, SEE DOCTOR.
INGESTION: DIL UTE WITH WATER. DO NOT INDUCE VOMITING.SEE DOCTOR.
* Fire Fighting Measures *
Flash Point:NOT REQUIRED
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
* Accidental Release Measures *
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE-ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTAN T AND THEN SHOVEL OR MOP UP
CONTAMINATION.
*Handling and Storage *
Handling and Storage Precautions:GASKET IS NONFRIABLE & WILL NOT SHED
FIBERS IN NORMAL USE AND STORAGE. USED GASKETS SHALL BE WETTED
BEFORE, DURING & AFTER DISASSEMBLY FROM AN ENGINE.
Other Precautions:IF IT IS NECESSARY TO CUT OR IMPACT THE GASKET WHILE
INSTALLING IT, WEAR A RESPIRATOR AND PROTECTIVE CLOTHING. USED
GASKETS SHALL BE IDENTIFIED AND DISPOSED OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDERAL REGULATIONS.
* Physical/Chemical Properties *
HCC:T6
Solubility in Water:INSOLUBLE
Appearance and Odor:COMPOSITION NONMETALLIC MATERIAL
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, AND STRONG ALKALIS
Stability Condition to Avoid:ACCUMULATIONS OF DUST
Hazardous Decomposition Products:ASBESTOS DUST
* Disposal Considerations *
Waste Disposal Methods:WET THE MATERIAL WITH WATER AND SURFACTANT.
PLACE IN 6 MIL THICK POLYETHYLENE PLASTIC BAG. PLACE THESE BAGS
INTO ANOTHER POLY BAG OR A SAFE PLACE UNTIL IT CAN BE SHIPPED TO AN
APPROVED DISPOSAL SITE. IDENTIFY WITH ASBESTOS CANCER WARNING
LABEL.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATORS RECOMMENDED FOR
NUISANCE DUST
Ventilation:LOCAL RECOMMENDED TO REMOVE DUST & FUMES
Other Protective Equipment:AS NEXESSARY FOR GOOD HYGIENE & CLEAN WORK
ENVIRONMENT
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PHENOL
Fraction by Wt: 3%
OSHA PEL:S, 5 PPM
Ingred Name:NON HAZARDOUS INGREDIENTS (AS SPECIFIED BY MFR)
* Hazards Identification *
Effects of Overexposure:NONE SPECIFIED BY MFR.POSS.SKIN,EYE,RESPIRATORY
IRRITATION DUE TO DUST.
* First Aid Measures *
MIN.AVOID INGESTION.CONSULT A DR.
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL,WATER,CARBON DIOXIDE
Fire Fighting Procedures:SELF CONT BREATHING GEAR IN ENCLOSED AREA
Unusual Fire/Explosion Hazard:AVOID DUST ACCUMULATIONS OR DUST-LADEN
ATMOSPHERES-DUST/AIR MIXTURES ARE EXPLOSIVE
* Accidental Release Measures *
Spill Release Procedures:VACUUM OR SWEEP WITH SAWDUST,SAND OR SWEEPING
COMPOUND,AVOID GENERATING DUST
*Handling and Storage *
Handling and Storage Precautions:AVOID TEMP EXTREMES & MOISTURE-CAN
AFFECT PRODUCT PERFORMANCE.AVOID PROLONGED OR REPEATED SKIN & EYE
CONTACT OR BREATHING OF VAPORS.
Other Precautions:USE ADEQUATE VENTILATION.USE GOOD PERSONAL HYGIENE.
* Physical/Chemical Properties *
HCC:T2
NRC/State Lic Num:EXPLOSIVE LIMIT
Boiling Pt:B.P. Text:NONE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRANULAR-SLIGHT PHENOLIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MFR
Hazardous Decomposition Products:CO*2,CO,PHENOLS,AMMONIA,FORMALDEHYDE
* Disposal Considerations *
Waste Disposal Methods:BURY OR INCINERATE IN ACCORDANCE WITH
LOCAL,STATE OR FEDERAL REGS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA-APPROVED RESPIRATOR OR SCBA AS
APPROPIATE FOR EXPOSURE OF CONCERN.
Ventilation:MECHANICAL (GENERAL) VENTILATION OR LOCAL EXHAUST
VENTILATION TO KEEP EXPOSURE LEVELS BELOW PEL.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO MINIMIZE
EXPOSURE FROM PROLONGED OR REPEATED CONTACT. EYE BATH AND SAFETY
SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
COMPANY STATES THEY NO LONGER MAKE THIS PRODUCT AND MSDS IS NOT
AVAILABLE. MSDS WAS GENERATED BY DGSC-SSH.
* Product Identification *
Preparer's Name:DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:TITANIUM DIOXIDE
Other REC Limits:NONE SPECIFIED
COULD BE EITHER SILICATES OR BARIUM SULFATE)
Other REC Limits:NONE SPECIFIED
Ingred Name:DRYING OIL MODIFIED PHTHALIC-ALKYD RESIN
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:AROMATIC COMPOUNDS
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:ETHYLBENZENE
Other REC Limits:NONE SPECIFIED
Ingred Name:TOLUENE (SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:ANTIOXIDANTS
Other REC Limits:NONE SPECIFIED
Ingred Name:WETTING AGENTS
Other REC Limits:NONE SPECIFIED
Ingred Name:STABILIZERS
Other REC Limits:NONE SPECIFIED
Ingred Name:WATER
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE AND SKIN IRRITATION.
ANAESTHETIC EFFECT IF INHALED. MAY CAUSE CENTRAL NERVOUS SYSTEM
EFFECTS. CHRONIC: DERMATITIS.
CARCINOGENIC INGREDIENTS.
Effects of Overexposure:EYES/SKIN: IRRITATION. INHALATION: RESPIRATORY
SYSTEM IRRITATION, HEADACHE, DIZZINESS, CONFUSION.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH A HISTORY OF SKIN
AND RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
IRRITATION PERSISTS, SEE DOCTOR. SKIN: WASH WITH MILD SOAP AND
WATER WHILE REMOVING CONTAMINATED CLOTHING AND SHOES. INHALATION:
REMOVE VIC TIM TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED. SEE DOCTOR.
INGESTION: DO NOT INDUCE VOMITING. IF SPONTANEOUS VOMITING OCCURS,
KEEP HEAD BELOW KNEE LEVEL TO PREVENT ASPIRATION. SEE DOCTOR.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE PERSONNEL. ELIMINATE IGNITION SOURCES.
VENTILATE AREA. WEAR PROTECTIVE CLOTHING AND EQUIPMENT. ABSORB IN
INERT MATERIAL AND PLACE IN APPROPIATE DISPOSAL CONTAINER AND
COVER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE, HEAT, IGNITION SOURCES AND
INCOMPATIBLE MATERIALS. KEEP CONTAINERS CLOSED.
Other Precautions:AVOID EYE AND SKIN CONTACT. DO NOT BREATHE VAPORS.
PROVIDE NENTILATION OR RESPIRATORY PROTECTION DURING WELDING OR
FLAME CUTTING OF COATED SURFACES.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:>1
Spec Gravity:1.2
Evaporation Rate & Reference:<1 (ETHER = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY LIQUID. HYDROCARBON ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
INCOMPLETELY BURNED CARBON PRODUCTS.
* Disposal Considerations *
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATORY PROTECTION
APPROPRIATE FOR THE HAZARD PRESENTED.
Ventilation:ENGINEERING CONTROLS.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . PROTECTIVE CLOTHING.
Work Hygienic Practices:FOR GOOD PERSONAL HYGIENE, INSURE PROMPT
REMOVAL FROM SKIN, AND CLOTHING.
Supplemental Safety and Health
FIRST AID PROC: IF IRRIT/BRTHG DFCLTY DEVELOPS, GET MED ADVICE BY
* Product Identification *
Product ID:BUFF-UP SPRAY FURNITURE POLISH
* Composition/Information on Ingredients *
Ingred Name:DISTILLATES (PETROLEUM), HYDROTREATED LIGHT; (MINERAL
SPIRITS)
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:ISOBUTANE; (2-METHYL PROPANE)
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:PROPANE
Other REC Limits:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PROD CAN AFFECT BODY IF IT
CONTACTS SKIN/EYES, IS INHALED/INGESTED. SKIN/EYES: NOT A PRIMARY
IRRITANT. INGEST: MAY CAUSE IRRIT OF MOUTH & THROAT, UPSET STOMACH,
NAUSEA, VOMITING, & DIARRHEA. DUE TO AEROSOL NATURE OF THIS PROD,
INGEST IS UNLIKELY. INHAL: MAY CAUSE IRRIT OF NOSE, THROAT, &
LUNGS. NOTES: INHAL EFFECTS OF THIS PROD OTHER THAN RESPIRATORY
IRRIT HAVE NOT BEEN DETERMINED. INHAL EFFE CTS OF INDIVIDUAL
INGREDIENTS ARE NOTED BELOW. A PREDICTION AS TO WHETHER THESE
EFFECTS WILL BE EXHIBITED BY PROD AS A WHOLE IS DEPENDENT ON AN
EVALUATION OF PRODS' USE & EXTENT & DURATION OF EXPOS. ( EFTS OF
OVEREXP)
Effects of Overexposure:HLTH HAZ: HIGH VAPOR/MIST CONCENTRATIONS OF
MINERAL SPIRITS ARE IRRITATING TO EYES & RESP TRACT & MAY CAUSE
HEADACHES, DIZZINESS, ANESTHESIA, DROWSINESS, UNCONSCIOUSNESS &
OTHER CNS EFFECTS, INCLUDING DEATH. SMALL AMOUNTS ASPIRATED INTO
RESP SYSTEM DURING VOMIT/INGEST MAY CAUSE MILD TO MODERATE
PULMONARY INJURY, POSSIBLY PROGRESSING TO DEATH. MFR OF THIS MATL
HYDROCARBON. INHAL EXPOS TO ISOBUTANE & PROPANE MAY CAUSE
DROWSINESS, LOSS OF CONSCIOUSNESS, ASPHYXIA & DEATH. OSHA PEL FOR
ASPHYXIANT.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND EYE, AND
RESPIRATORY DISORDERS.
* First Aid Measures *
First Aid:SKIN: RINSE THORO W/WATER. EYES: REMOVE CONT LENSES. RINSE
EYELIDS OPEN. IF IRRIT DEVELOPS, GET MED ADVICE BY CALLING EMER
NUMBER ON PAG E 1 OF MSDS, OR LOC/REGIONAL POIS CTL CTR/HOSPITAL
EMER ROOM. INGEST: IF VICTIM IS A CHILD, GIVE 4-8 OZ OF WATER. FOR
SWALLOWED. IF VOMI T OCCURS SPONT, KEEP VICTIM IN UPRIGHT POSITION.
LOC/REGIONAL POIS CTL CTR/HOSPITAL EMER ROOM. INHAL: REMOVE TO
FRESH AIR. (SUP DAT)
* Fire Fighting Measures *
Flash Point:SEE SUP DAT
Extinguishing Media:USE WATER SPRAY, FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WEAR PROTECTIVE EQUIPMENT TO PROTECT AGAINST PRODUCTS
OF COMBUSTION (E.G., CO, CO*2, NO*2, COCL*2, HCL, SMOKE, SOOT,
UNIDENTIFIED ORGANICS) . COOL CONTAINERS W/WATER. VAPOR PRESSURE
BUILD-UP DUE TO FIRE HEAT MAY CAUSE CONTAINER RUPTURE & ROCKETING.
Unusual Fire/Explosion Hazard:PRODUCT IS CLASSIFIED AS A COMPRESSED GAS
AND A FLAMMABLE AEROSOL. PRODUCT PROPELLANT IS A FLAMMABLE
AEROSOL.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE POTENTIAL IGNITION SOURCES. WEAR
APPROPRIATE PERSONAL PROTECTION EQUIPMENT (NIOSH APPROVED
CLOTHING). CONTAIN/DIKE SPILL TO PREVENT ENVIRONMENTAL RELEASE.
*Handling and Storage *
Handling and Storage Precautions:THIS PRODUCT IS A CONSUMER PRODUCT. TO
THE EXTENT THE PRODUCT IS USED IN A FASHION TYPICAL TO THAT OF A
CONSUMER, PROTECTIVE MEASURES, WITH THE EXCEPTION OF THOSE
INDICATED ON THE LABEL, ARE NOT NORMA LLY NECESSARY.
Other Precautions:WHERE USE CNDTNS &/OR EXTENT & DURATION OF EXPOS
DIFFER FROM TYPICAL CONSUMER USE, HOWEVER, APPROP PROT MEASURES TO
CLTHG) & MIN INHAL EX POS (ENGINEERING CTLS, NIOSH-APPRVD RESP PROT
APPROP FOR HAZ PRESENTED) ARE RECOMMENDED.
* Physical/Chemical Properties *
Spec Gravity:SEE SUP DAT
Appearance and Odor:THIS PRODUCT IS A WHITE, SEMI-VISCOUS EMULSION WITH
A LEMON-OIL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH ACIDS, STRONG OXIDIZERS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT, FLAME.
* Ecological Information *
Ecological:NO INFORMATION.
* Disposal Considerations *
Waste Disposal Methods:THIS PRODUCT IS A U.S. EPA RCRA HAZARDOUS WASTE.
DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.
* MSDS Transport Information *
Transport Information:DOT PROPER SHIPPING NAME: PAINT. DOT HAZARD
PACKING GROUP: III.
* Regulatory Information *
SARA Title III Information:BUTYL ALCOHOL IS SUBJECT TO REPORTING
Federal Regulatory Information:+PIGMENT CONTENT IS DEPENDENT ON COLOR.
ALL INGREDS ARE ON TSCA INVENTORY OR ARE EXEMPT. U.S. FED REGS: AS
FOLLOWS - OSHA: HAZARDUS BY DEFINITION OF HAZARD COMMUNICATION
CANADIAN WHMIS: THIS MSDS HAS BEEN PREPARED IN COMPLIANCE WITH
CANADIAN WHMIS CLASS: NO INFORMATION AV AILABLE.
WARNING: THIS PRODUCT CONTAINS CHEM KNOWN TO STATE OF CALIFORNIA TO
CNTNS CHEM KNOWN TO STATE O F CALIFORNIA TO CAUSE BIRTH
DEFECTS/OTHER REPRODUCTIVE HARM. NEW JERSEY RIGHT-TO-KNOW: NO
NON-HAZARDOUS MATLS ARE AMONG TOP 5 INGREDIENTS. PENNSYLVANIA
RIGHT-TO-KNOW: NO NON-HAZARDOUS INGREDIENTS ARE PRESENT AT GREATER
THAN 3%.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF WORKPLACE XPOS LIM(S) OF PROD/ANY COMPONENT
IS EXCEEDED (SEE EXPOS GUIDELINES), NIOSH APPRVD AIR SUPPLIED RESP
IS ADVISED IN ABSENCE OF PROPER ENVIR CTL. OSHA REGS ALSO PERMIT
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOC EXHAUST)
VENT TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING & BOOTS. ANSI
APPRVD EMERGENCY EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
* Product Identification *
Product ID:MACS HEAVY DUTY PASTE RUBBING COMPOUND
* Composition/Information on Ingredients *
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (ALIPHATIC PETROLEUM
DISTILLATES)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TALL OIL
Fraction by Wt: 0-9%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PINE OIL
Fraction by Wt: 0-7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:DEATH. IARC HAS DETERM THERE IS SUFFICENT EVID FOR
CARCINOGENICITY OF CRYSTALLINE SILICA TO EXPERIMENTAL (ING 6)
Ingred Name:ING 5:ANIMALS, & THAT THERE IS LIMITED EVID OF
CARCINOGENICITY OF CRYSTALLINE SILICA TO HUMANS. IARC CLASS 2A.
Ingred Name:FIRST AID PROC:ATTN. IF POSS, DO NOT LEAVE INDIVIDUAL
UNATTENDED. INHAL:IMMED MOVE INDIVIDUAL AWAY FROM EXPOS (ING 8)
Ingred Name:ING 7:& INTO FRESH AIR. SEEK IMMED MED ATTN; KEEP PERSON
WARM & QUIET. IF PERSON IS NOT BRTHG, BEGIN ARTF RESP. (ING 9)
Ingred Name:ING 8:IF BRTHG IS DIFFICULT, ADMINISTER OXYGEN.
Ingred Name:SPILL RELEASE PROC:COMPLETED. STOP SPILL @ SOURCE. PVNT
STREAMS/OTHER BODIES OF WATER. IF RUN-OFF OCCURS, NOTIFY PROPER
Ingred Name:RESP PROT:SPECIFIED CNDTNS (CONSULT YOUR INDUST HYGIENIST.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:CAUSES IRRIT. SYMPS MAY INCL
STINGING, TEARING, REDNESS & SWELL. SKIN:MILD IRRIT. PRLNGD/RPTD
EXPOS MAY DRY SKIN. SYMPS MAY INCL REDNESS, BURNING, DRYING &
CRACKING, & SKIN BURNS. INGEST:SIN GLE DOSE ORAL TOX IS LOW.
SWALLOWING SMAMTS DURING NORM HNDLG IS NOT LIKELY TO CAUSE HARMFUL
EFTS; (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
ON CARCINS. (SUPDAT)
Effects of Overexposure:HLTH HAZ:SWALLOWING LG AMTS MAY BE HARMFUL.
MATL CAN ENTER LUNGS DURING SWOLLOWING/VOMIT & CAUSE LUNG INFLAMM
&/OR DMG. EXPOS TO VAP/MIST IS POSS. SHORT-TERM INHAL TOX IS LOW.
BRTHG SM AMTS DURING NOR M HNDLG IS NOT LIKELY TO CAUSE HARMFUL
EFTS; BRTHG LG AMTS MAY BE HARMFUL. SYMPS OF EXPOS:GI IRRIT (NAUS,
VOMIT,(SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS MATERIAL. PRE-EXISTING LUNG
DISORDERS, E.G. ASTHMA-LIKE CONDITIONS MAY BE AGGRAVATED BY
EXPOSURE TO MATERIAL.
* First Aid Measures *
First Aid:EYES:IMMED MOVE INDIVIDUAL AWAY FROM EXPOS & INTO FRESH AIR.
SEEK IMMED MED ATTN. SKIN:REMOVE CONTAMD CLTHG. WASH EXPOS AREA
W/SOAP & WATER. IF SYMPS PERSIST, SEEK MED ATTN. LAUNDER CLTHG
BEFORE REUSE. INGEST:DO NOT INDUCE VOMIT. MATL IS ASPIR HAZ. IF
INDIVIDUAL IS DROWSY/UNCON, PLACE ON LEFT SIDE W/HEAD DOWN. SEEK
MED (ING 7)
* Fire Fighting Measures *
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . REFER TO
PERSONAL PROTECTIVE EQUIPMENT SECTION OF MSDS.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND/BE MOVED BY VENT & IGNITED BY HEAT, PILOT LIGHTS, OTHER
FLAMES & IGNIT SOURCES @ LOCATIONS DISTANT FROM MATL (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:SM SPILL:ABSORB LIQ ON VERMICULITE, FLOOR
ABSORB/OTHER ABSORB MATL. LG SPILL:ELIM ALL IGNIT
SOURCES(FLARES,FLAMES INCLDG PILOT LIGHT, ELEC SPKS). PERSONS NOT
WEARING PROT EQUIP SHOULD BE EXCLUDED FROMAREA OF SPILL UNTIL
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:CONTAINERS OF MATL MAY BE HAZARDOUS
WHEN EMPTIED.
Other Precautions:SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES
(VAPOR, LIQUID, AND/OR SOLID), ALL HAZARD PRECAUTIONS GIVEN IN DATA
SHEET MUST BE OBSERVED.
WELDING/CUTTING TORCH ON/NEAR DRUM (EVEN EMPTY) BECAUSE PROD (EVEN
JUST RESIDUE) CAN IGNITE EXPLO. EXPLAN OF CARCIN:ANTIC TO BE
CARCIN. EFT S OF OVEREXP:DIARR), IRRIT (NOSE, THROAT, RESP TRACT),
CNS DEPRESS (DIZZ, DROW, WEAK, FATG, NAUS, HDCH, UNCON), &(ING 5)
* Physical/Chemical Properties *
Vapor Density:>1.0
Evaporation Rate & Reference:SLOWER/ETHYL ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:LIQUID.
Percent Volatiles by Volume:SUPDAT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH: STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM: CARBON DIOXIDE AND CARBON
MONOXIDE, VARIOUS HYDROCARBONS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF DUSTY CONDITIONS PREVAIL, USE OF AN APPROVED
NIOSH DUST MASK IS RECOMMENDED.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . WEAR LONG SLEEVE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PREC: IF LGE QTY OF SIEVE QUICKLY ABSORBS EQUILIBRIUM AMT OF WATER,
SIEVES CAN BECOME HOT ENOUGH TO CAUSE THERMAL BURNS OF SKIN. AVOID
CONT UNDER THESE CNDTNS. WHEN TRANSFERRING BEADED MOLECULAR SIEVES
W/HIGH PRESS AIR, WEAR GOGGS. (ING 9)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM OXIDE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CALCIUM OXIDE
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:POTASSIUM OXIDE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA GEL; (SILICA (SYNTHETIC))
OSHA PEL:6 MG/M3
Ingred Name:CLAY (KAOLIN); (CLAY)
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:SILICA, CRYSTALLINE - FUSED; (QUARTZ)
Fraction by Wt: <3%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:WATER
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: MALFUNCTION OF EQUIP CAN PROPEL BEADS W/ENOUGH
Ingred Name:ING 9: AND RECEIVING VESSELS ARE PROPERLY GROUNDED. FOLLOW
STANDARD OPERATING INSTRUCTIONS.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MOLECULAR SIEVES ARE
NON-FIBROUS, SYNTHETIC ALUMINOSILICATES (ZEOLITES) NOT TO BE
CONFUSED W/NATRL ZEOLITES. ALL STUDIES TO DATE INDICATE THAT THEY
DO NOT CAUSE SIGNIFICANT HLTH PROBLEMS. WHEN ACTIVATED, MOLECULAR
SIEVES ACT AS A DESICCANT & CAN CAUSE DRYING IRRIT OF MUC MEMBS &
SKIN IN CASES OF SEV EXPOS.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-FUSED: IARC MONO,
TO BE CARCIN.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYES: IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER,
MINUTES. IF IRRITATION OCCURS AND PERSISTS, SEEK MEDICAL ATTENTION.
SKIN: WASH WITH S OAP AND WATER. INGESTION: MATERIAL WILLPASS
THROUGH BODY NORMALLY. CALL MD IMMEDIATELY . INHALATION: REMOVE TO
FRESH AIR.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:VACUUM OR SWEEP UP OR FLUSH TO SEWER TREATED
FOR SUSPENDED SOLIDS REMOVAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NOT A FOOD-GRADE PRODUCT. KEEP
CONTAINERS TIGHTLY SEALED TO PROTECT PRODUCT QUALITY. AVOID
PROLONGED BREATHING OF DUST OR CONTACT OF DUST WITH SKIN.
Other Precautions:DRYING ACTION OF THIS MATL CAN CAUSE IRRIT OF MUC
MEMBS OF NOSE & THROAT & IRRIT OF SKIN. WHEN POURING INTO CONTR OF
FLAM LIQ, GROUND BOTH CONTRS ELECTRICALLY TO PVNT STATIC ELEC
SPARK. WILL RELEASE H EAT WHEN ABSORBING WATER. (SUP DAT)
* Physical/Chemical Properties *
Spec Gravity:2.1
pH:SUPDAT
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE, GRAY, OR TAN BEADS; ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REACTS WITH HF AND STRONG ACIDS OR ALKALI.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:LANDFILL IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. COVER TO AVOID BLOWING OF DUST.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
Ventilation:PROVIDE DILUTION/LOCAL EXHAUST TO PREVENT BUILD UP OF
VAPORS. USE EXPLOSION PROOF EQUIPMENT. USE NON-SPARKING EQUIPMENT.
Other Protective Equipment:EYE WASH & SAFETY SHOWER, IMPERVIOUS
CLOTHING, FACE SHIELD, APRON, BOOTS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER HANDLING, ESPECIALLY BEFORE EATING/SMOKING.
Supplemental Safety and Health
FIRE HAZ CONT'D: VAPORS MAY IGNITE EXPLOSIVELY AT AMBIENT TEMPS & FORM
EXPLOSIVE MIXTURES IN AIR AT ELEVATED TEMPS. INCOMPATIBILITES
CONT'D: MAGNESIUM, CAUSTICS, SODIUM, POTASSIUM. HEALTH HAZ INGEST C
ONT'D: LUNG INFLAMMATION, DAMAGE DUE TOASPIRATION INTO THE LUNGS.
CNS DEPRESSION. BURNS OF THE MOUTH, THROAT & STOMACH.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CRYSTALLINE-QUARTZ SILICA, SILICA DUST (SUSPECTED HUMAN
ACGIH TLV:0.1 MG/CUM RESP DUST
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT/MUCOUS
MEMBRANE IRRITANT. CNS DEPRESSION/ANESTHETIC. MAY CAUSE DAMAGE TO
LIVER/KIDNEY & CAUSE PULMONARY
EDEMA/PNEUMOCONIOSIS/ASPHYXIATION/DEATH. SKIN: SEVERE IRRITANT/BUR
NS/DERMATITIS W/PROLONGED/REPEATED CONTACT. EYES: SEVERE
IRRITANT/BURNS/CONJUNCTIVITIS & CORNEAL INJURY. (SEE SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of
Overexposure:IRRITATION/FATIGUE/DROWSINESS/DIZZINESS/LIGHTHEADEDNES
S/HEADACHE/INCOORDINATION/NAUSEA/VOMITING/COUGHING/CHOKING/INTOXICA
TION/TIGHTNESS OF CHEST/NARCOSIS/DIFFICULTY
BREATHING/BURNS/UNCONSCIOUSNESS/CYA
NOSIS/ASPHYXIATION/DEFATTING/BLISTERINGOF SKIN/BLURRED
VISION/TEARING/REDNESS/INFLAMMATION/DIARRHEA/ABDOMINAL PAIN.
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS,
ASTHMA-LIKE CONDITIONS, LUNG, KIDNEY & LIVER DISORDERS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE/SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY. SKIN:
FLUSH W/WATER, THEN WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH
IRRITATION PERSIST, HOLDING EYES OPEN DURING FLUSHING. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL/FOAM WATER FOG, CO2
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINED BREATHING APPARATUS IS RECOMMENDED.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT/FIRE. VAPORS ARE >AIR & MAY TRAVEL LONG
DISTANCES TO AN IGNITION SOURCE & FLASHBACK. (SEE SUPP)
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE AREA
W/EXPLOSION PROOF EQUIPMENT. COLLECT LEAKS W/ABSORBENT. USE
NON-SPARKING TOOLS. EVACUATE. PLACE MATERIAL IN PROPER CONTAINER.
LARGE: SHUT OFF LEAK SAFELY. DI KE/CONTAIN. PUMP TO STORAGE/SALVAGE
VESSELS. (SUPP
*Handling and Storage *
SOURCES. USE W/ADEQUATE VENTILATION. KEEP CONTAINERS TIGHTLY
CLOSED/UPRIGHT WHEN NOT IN USE. DON'T TAKE INTERNALLY.
Other Precautions:AVOID CONTACT W/SKIN/EYES & BREATHING OF VAPORS. KEEP
OUT OF REACH OF CHILDREN. AVOID CONDITIONS THAT FORM INHALABLE
PARTICLES DUE TO SPRAYING/ABRADING PAINTED SURFACES. GROUND
EQUIPMENT WHEN TRANSFER RING TO PREVENT ACCUMULATION OF STATIC.
* Physical/Chemical Properties *
Appearance and Odor:GLID-GUARD EPOXY SURFACING COMPOUND AGGREGATE (PART
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, REDUCING AGENTS, BASES, ALDEHYDES, KETONES, AMINES,
ALUMINUM, ZINC, COPPER, IRON, MERCAPTANS (SEE SUPP
Stability Condition to Avoid:EXTREME HEAT/FIRE, ELEVATED
TEMPS/SPARKS/OPEN FLAME & OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN, AMMONIA,
OXYGEN, ALDEHYDES, BARIUM COMPOUNDS, UNIDENTIFIED ORGANIC
COMPOUNDS.
* Disposal Considerations *
Waste Disposal Methods:KEEP SALVAGEABLE MATERIAL & RINSE WATER OUT OF
SEWERS & WATER COURSES. AVOID DISCHARGE TO NATURAL WATERS. DISPOSE
OF IAW/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NO SPECIAL REQUIREMENTS.
Ventilation:ADEQUATE TO ELIMINATE MISTS
Other Protective Equipment:FULL WORK CLOTHING; FACE SHIELD WHEN USING/
MIXING PRODUCT.
Work Hygienic Practices:WASH HANDS AFTER HANDLING.
Supplemental Safety and Health
ITEM IS A 2 PART KIT;THIS ENTRY DESCRIBES PART A.SOLUTION
BY THIS MSDS IS OBSOLETE. MSDS GENERATED FROM MSDS IN HMIS FOR
NOT HSVE P/N FOR THE OLD NSN.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:HYDROQUINONE (SARA III)
OSHA PEL:2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY CAUSE SKIN/EYES IRRITATION
ON CONTACT;CHRONIC:PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE
IRRITATION AND MAY CAUSE SKIN ALLERGIC REACTION.
Effects of Overexposure:SKIN: REDNESS, ITCHING. EYES: REDNESS, TEARING,
DISCOMFORT.
* First Aid Measures *
First Aid:INHALE: REMOVE TO FRESH AIR, GIVE ARTIFICIAL RESPIRATION OR
DOCTOR; SKIN:FLUSH WITH LOTS OF WATER;INGESTED: RINSE MOUTH; GET
IMMEDIA TE MEDICAL ATTENTION FOR EYES OR INGESTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN & EYES.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF DECOMPOSITION PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:WEAR APPROPRIATE PROTECTIVE EQUIPMENT. STOP
LEAK WITHOUT RISK. ABSORB WITH INERT MATERIAL, SCOOP UP AND PLACE
IN A CONTAINER FOR LATER DISPOSAL. MANUFACTURER SUGGESTS TO FLUSH
MATERIAL TO AN ACID-FREE SEWER WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA; PROTECT FROM PHYSICAL DAMAGE & AVOID CONTACT.KEEP CONTAINERS
TIGHTLY CLOSED.
Other Precautions:REMOVE & WASH CONTAMINATED CLOTHING. MAINTAIN STRICT
HYGIENE.USE OF NON-ALKALINE(ACID) TYPE HAND CLEANER REDUCES RISK OF
ALLERGIC SKIN REACTION.USE PROTECTIVE.EQUIP TO PREVENT SKIN
CONTACT.
* Physical/Chemical Properties *
HCC:B1
Vapor Density:0.6
pH:6.5
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,TARNISH COLORED SOLUTION,ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS,STRONG OXIDIZERS
Stability Condition to Avoid:HEAT,HIGH TEMPERATURES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION WILL EMIT OXIDES
OF CARBON, S, & N2.
* Disposal Considerations *
Waste Disposal Methods:MANUFACTURER STATES THAT DISCHARGE, TREATMENT,
OR DISPOSAL MAY BE SUBJECT TO FEDERAL, STATE, OR LOCAL LAWS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH APPROVED RESPIRATOR IF THE AREA IS
POORLY VENTILATED.
Ventilation:LOCAL EXHAUST RECOMMENDED TO CONTROL VAPOR LEVELS IF
PRODUCT IS HEATED. GENERAL EXHAUST ADEQUATE AT AMBIENT TEMPS.
Other Protective Equipment:CLEAN PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE & LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
DATA REFERS TO THE MIXTURE OF PARTS A & B EXCEPT FOR APPEARANCE &
* Product Identification *
Kit Part:Y
Preparer's Name:R STOLLEY
* Composition/Information on Ingredients *
Ingred Name:MODIFIED ALIPHATIC POLYAMIDE
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITATION. EYES: IRRITATION, BURNS, CHRONIC CONTACT CAN LEAD TO
ABSORPTION, PERMANENT INJURY. SKIN: IRRITATION, BURNS, CHRONIC
CONTACT CAN LEAD TO SENSITIZATION, ABSORPT ION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNS, NAUSEA, ABDOMINAL PAIN,
ASTHMA-LIKE SYMPTOMS
Medical Cond Aggravated by Exposure:SENSITIVE SKIN
* First Aid Measures *
First Aid:INHALATION: MOVE TO FRESH AIR. GIVE CPR/OXYGEN AS REQUIRED.
EFFECTIVE W/IN ONE MINUTE. SKIN: WASH W/SOAP & WATER. APPLY
EMOLLIENT RI CH CREAM. INGESTION: ASPIRATION HAZARD.DON'T INDUCE
VOMITING. NOTE TO PHYSICIAN: GASTRIC LAVAGE IS INDICATED IF
UNREACTED PASTE IS INGESTED IN LARGE AMOUNTS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA & CLEAN, PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:TOXIC FUMES WILL BE GIVEN OFF WHEN THIS
MATERIAL IS INVOLVED IN A FIRE.
* Accidental Release Measures *
Spill Release Procedures:AVOID PERSONAL CONTACT. TAKE UP W/ABORBANT
MATERIAL & PUT INTO CLOSED CONTAINERS FOR PROPER DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT W/EYES, SKIN & CLOTHING.
Other Precautions:AVOID BREATHING VAPOR/MIST.
* Physical/Chemical Properties *
Vapor Pres:0
Vapor Density:>1
Spec Gravity:1.8
Evaporation Rate & Reference:(BU AC=1): 0
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREY OPAQUE PASTE W/MERCAPTAN ODOR
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS, ALKALIS
Hazardous Decomposition Products:CO, ALDEHYDES, OXIDES OF NITROGEN
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:PROPERLY FITTED NIOSH APPROVED ORGANIC
VAPOR/PARTICULATE RESPIRATOR.
Ventilation:LOCAL EXHAUST: PREFERABLE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:DRYING INDUSTRIAL ENAMEL.
* Product Identification *
CAGE:0D4B9
CAGE:0D4B9
* Composition/Information on Ingredients *
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Ingred Name:NEPHELINE SYENITE
OSHA PEL:N/K
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:CALCIUM CARBONATE
Ingred Name:BARIUM SULFATE
Ingred Name:STODDARD SOLVENT; (MINERAL SPIRITS)
Ingred Name:CARBON BLACK
Fraction by Wt: 1.9%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:COPPER, (PHTHALOCYANINATO(2-))-; (PHTHALO BLUE). ACGIH
Fraction by Wt: 1.3%
OSHA PEL:N/K
ACGIH TLV:SEE INGREDIENT
Ingred Name:PERM-YELLOW; (AZO YELLOW)
Fraction by Wt: 4.7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:2-NAPHTHOL, 1-((2,4-DINITROPHENYL)AZO)-; (DINITRANILINE
ORANGE)
Fraction by Wt: 2.7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:C.I. PIGMENT GREEN 7; (PHTHALO GREEN)
Fraction by Wt: 2.2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:2-NAPHTHALENOL, 1-((4-METHYL-2-NITROPHENYL)AZO)-; (AZO RED)
Fraction by Wt: 5.7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHYL ALCOHOL; (ETHANOL)
Fraction by Wt: 0.5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM MAY OCCUR ON OVEREXPOSURE. MAY ALSO CAUSE
NERVOUS SYSTEM DEPRESSION. HEADACHE, DIZZINESS, NAUSEA AND LOSS OF
COORDINATION ARE INDICATIONS OF EXCES SIVE EXPOSURE TO VAPORS OR
SPRAY MISTS.CHRONIC:REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED
OCCUP (EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ:OVEREXPOSURE TO SOLVENTS W/PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
INHALING CONTENTS CAN BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE FROM EXPOSURE.
RESTORE BREATHING. KEEP WARM & QUIET. SKIN:WASH AFFECTED AREA
THOROUGHLY W/SOAP & WATER. EYES:FLUSH W/LARGE AMOUNTS OF WATER FOR
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:0.9%
Extinguishing Media:FOR DRY SOLIDS, USE WATER, FOAM, CO*2, DRY
CHEMICALS.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER MAY BE USED TO COOL CLSD CNTNRS TO PVNT PRESS BUILD-UP & POSS
AUTO-IGNIT/EXPLO WHEN EXPOS TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELECTRICAL EQUIPMENT, SPARKS & OPEN FLAME. HEAT MAY CAUSE
PRESS BUILD-UP IN CLSD CNTNRS. WATER MAY BE USED TO COOL.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE & REMOVE
W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:CONTENTS ARE COMBUSTIBLE. KEEP AWAY
FROM HEAT & OPEN FLAME. USE APPRVD BONDING & GROUNDING PROCS.
TRANSFER ONLY TO APPRVD, PROPERLY MARKED CNTNRS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:COLORED PIGMENT LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE - CARBON DIOXIDE, CARBON
MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF I/A/W FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
SPILL PROC: FEDERAL, STATE AND LOCAL REGULATIONS ON REPORTING RELEASES.
REFER TO REGULATORY INFO FOR REPORTABLE QUANTITY AND OTHER
REGULATORY DATA. EXPOSURE GUIDELINES: MAGNESIUM SULFATE - NO OSHA
ORACGIH EXPOSURE LIMITS HAVE BEEN ESTABLISHED.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MAGNESIUM SULFATE HEPTAHYDRATE; (MAGNESIUM SULFATE)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DUST INHALATION MAY IRRITATE UPPER
RESPIRATORY PASSAGES. CARCINOGENICITY: THE MATERIAL IS NOT LISTED
(IARC, NTP, OSHA) AS CANCER CAUSING AGENT.
Effects of Overexposure:SEE HEALTH HAZARDS.
* First Aid Measures *
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:
WASH THOROUGHLY WITH SOAP AND WATER. EYES: IMMEDIATELY FLUSH
REMOVE TO FRESH AIR. INGESTION: GET IMMEDIATE MEDICAL ATTENTION;
IF CONSCIOUS, GIVE WATER FREELY.
* Fire Fighting Measures *
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:USE ANY SUITABLE FOR ADJACENT MATERIAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCES TOXIC
FUMES.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA OF ALL UNNECESSARY PERSONNEL.
WEAR SUITABLE PROTECTIVE EQUIPMENT LISTED UNDER EXPOSURE/PERSONAL
PROTECTION. ELIMINATE ANY IGNITION SOURCES UNTIL THE AREA IS
DETERMINED TO BE FREE FROM EX PLOSION OR FIRE HAZARDS. CONTAIN THE
RELEASE AND ELIMINATE ITS SOURCE, IF THIS CAN BE DONE WITHOUT RISK.
TAKE UP AND CONTAINERIZE FOR PROPER DISPOSAL AS DESCRIBED UNDER
DISPOSAL. COMPLY WITH (SUPDAT)
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE AT
CONTROLLED ROOM TEMPERATURE. DO NOT BREATHE DUST. DO NOT GET IN
EYES. AVOID PROLONGED OR REPEATED SKIN CONTACT.
* Physical/Chemical Properties *
M.P/F.P Text:DECOMPOSE
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE, ODORLESS CRYSTALS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE INDICATED.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:SO*X.
* Toxicological Information*
TOXICOLOGICAL FINDINGS: NONE. CITED IN REGISTRY OF TOXIC EFFECTS OF
CHEMICAL SUBSTANCES (RTECS).
* Disposal Considerations *
Waste Disposal Methods:MATERIAL DOES NOT HAVE AN EPA WASTE NUMBER AND
IS NOT A LISTED WASTE, HOWEVER CONSULTATION WITH A PERMITTED WASTE
DISPOSAL SITE (TSD) SHOULD BE ACCOMPLISHED. ALWAYS CONTACT A
PERMITTED WASTE DISPOSER (TSD) TO ASSURE COMPLIANCE WITH ALL
CURRENT LOCAL, STATE AND FEDERAL REGULATIONS.
* MSDS Transport Information *
Transport Information:DOT PROPER SHIPPING NAME: NON-REGULATED. DOT ID
NUMBER: NONE.
* Regulatory Information *
Federal Regulatory Information:THIS PRODUCT IS A "MIXTURE." THE CAS
NUMBERS OF ALL COMPONENTS ARE LISTED ON THE TSCA INVENTORY.
State Regulatory Information:
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:DO NOT BREATHE VAPS, SPRAY MIST/SANDING DUST.
WHEN SPRAY APPLIED IN OUTDOOR/OPEN AREAS, & CURING SANDING/GRINDING
OPERATIONS, USE NIOSH/MSHA APPRVD MECH FILTER RESP TO REMOVE SOLID
Ventilation:PROVIDE GEN DILUTION/LOC EXHST VENT IN VOL & PATTERN TO
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
SOLV IMPERMEABLE CLTHG & BOOTS TO PREVENT SKIN CONT ARE
RECOMMENDED.
Work Hygienic Practices:DO NOT GET ON SKIN/IN EYES. REMOVE & WASH
SOILED CLTHG BEFORE REUSE. WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
FIRE FIGHT PROC: IF EXPOSED TO FIRE/EXTREME HEAT, WATER SHOULD BE USED
TO COOL CLSD CONTRS & PVNT PRESS BUILD UP/POSS AUTO-IGNIT. EXPLO
HAZ: USE WELDING/CUTTING TORCH ON/NEAR CONTR (EVEN EMPTY) AS PRO
D/ITS RESIDUE MAY IGNITE. DURING EMER CNDTNS OVEREXP TO DECOMP
PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED (ING 5)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:OTHER PREC: IS PART OF A 2 COMPONENT PROD, THEN MIXTURE OF
Ingred Name:ING 9: COMPONENTS. OBSERVE ALL APPLIC PREC. WARNING: THIS
Ingred Name:RESP PROT: WHEN USED IN RESTRICTED VENT AREAS, WEAR NIOSH
Ingred Name:VENT: HLTH STDS IN MIXING, APPLICATION & CURING AREAS & TO
LEVELS OF THE WORK AREA. ELIMINATE ALL IGNITION SOURCES.
Ingred Name:PHENOL, 2,4,6-TRIS(DIMETHYLAMINOMETHYL)-;
RAT):2.5 MG/KG
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: APPARENT. OBTAIN MEDICAL ATTENTION.
Ingred Name:FIRST AID PROC: INGEST: CONSULT MD IMMED. NOTICE:
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING (ING 7)
Ingred Name:ING 6: THE CONTENTS MAY BE HARMFUL OR FATAL.
Ingred Name:SPILL PROC: ABSORBENT AND NON-SPARKING TOOLS. STORE IN
CLOSED CONTAINER UNTIL PROPERLY DISPOSED OF.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: IRRIT OF RESP TRACT;
HDCH, NAUS, DIZZ, WEAK & FATG. EXTREME EXPOS CAN RSLT IN UNCON &
EVEN RESP ARREST. SKIN/EYES: IRRIT. MAY BE HARMFUL IF ABSORBED THRU
SKIN. CAUSES SKIN BURNS. INGEST: CAN CAUSE STOM &/INTESTINAL
IRRIT, NAUS, VOMIT & DIARR. CHRONIC: RPTS HAVE ASSOC RPTD & PRLNG
OCCUP (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: OVEREXP TO SOLV W/PERM BRAIN & NERV
SYS DMG. PRLNG/RPTD BRTHG PF SPRAY MIST &/SANDING DUST OVER A
PERIOD OF YEARS MAY CAUSE DUST DISEASE OF THE LUNGS.
Medical Cond Aggravated by Exposure:NONE, WHEN USED IN ACCORDANCE WITH
SAFE HANDLING AND USE INFORMATION.
* First Aid Measures *
First Aid:INHAL: IF YOU EXPERIENCE DFCLTY IN BRTHG, LEAVE AREA TO
OBTAIN FRESH AIR. IF CONTINUED DFCLTY IS EXPERIENCED, SUMMON MED
ASSIST IMMED. IF BRTHG CEASES, RESTORE USING APPRVD CPR TECHNIQUES
& SUMMON MED HELP IMMED. EYES: FLUSH IMMED W/LGE AMTS OF WATER FOR
WATER. REMOVE SOILED CLTHG. GET MED ASSIST IF IRRIT PERSISTS. (ING
6)
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, FOAM, OR OTHER
NFPA APPROVED METHOD FOR TREATING A CLASS B FIRE.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
SUMMON PROFESSIONAL FIREFIGHTERS. WATER SPRAY MAY BE INEFFECTIVE.
IF WATER IS USED, FOG NOZZ PREF. (SUP DAT)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS & FLAME. DUE TO PRESS BUILD-UP, CLSD
CONTRS EXPOSED TO EXTREME HEAT MAY EXPLODE. NEVER (SUP DAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT (FLAMES, HOT SURF,
& ELEC, STATIC/FRICTIONAL SPARKS). PVNT BRTHG OF VAPS. VENT AREA.
BEFORE ATTEMPTING CLEAN-UP, REFER TO HAZ CAUTION INFO IN OTHER
SECTIONS OF THIS MSDS. C ONTAIN SPILLED MATL & REMOVE W/INERT (ING
8)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAMES.
DO NOT SMOKE. PVNT BUILD-UP OF VAPS BY MAINTAINING CONTINUOUS FLOW
OF FRESH AIR.
NOT IN USE. DO NOT TRANSFER CONTENTS TO BOTTLES/OTHER UNLABELLED
CONTRS. DO NOT R EUSE EMPTY CONTRS. IF THIS MATL (ING 9)
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY CAUSE TOXIC FUMES WHEN HEATED TO
DECOMP. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE, OXIDES
OF NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST VENTILATION USUALLY SUFFICIENT. MECHANICAL
(GENERAL) VENTILATION IF NECESSARY.
Other Protective Equipment:NOT NORMALLY REQUIRED.
Work Hygienic Practices:STANDARD INDUSTRIAL PRACTICES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:COIL BRITE
Preparer's Name:A.B.
* Composition/Information on Ingredients *
Ingred Name:ETHANOL, 2-BUTOXY-; (ETHYLENE GLYCOL MONOBUTYL ETHER)
(EGBE) (2-BUTOXYETHANOL)
Ingred Name:SODIUM METASILICATE PENTAHYDRATE
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE & SKIN IRRIT, DEPENDING
ON CONC & LENGTH OF CONTACT TIME. EYES:IRRITATION. SKIN:RPTD/PRLNG
CONT MAY CAUSE DRYING OF SKIN. INHAL:HDCH, DIZZ, NAUS. ANIMAL
STUDIES HAVE CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON
CNS, HEMATOPOIETIC TISS, BLOOD, KIDNEYS & LIVER ASSOC W/ADMIN OF
ETHYLENE(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:GLYCOL MONOBUTYL ETHER (EGBE).
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O2/ARTF
MINUTES. IF IRRITATION PERSISTS, GET MD. SKIN:WASH W/SOAP & WATER.
INGEST :CALL MD IMMEDIATELY.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:SMALL SPILL:FLUSH TO DRAIN. LARGE SPILL:STOP
LEAK AT SOURCE. PUMP INTO APPROPRIATE SALVAGE CONTAINER. IF NOT
SALVAGEABLE OFFER FOR DISPOSAL.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:ALWAYS KEEP UNUSED PORTION OF PRODUCT
IN ITS ORIGINAL CONTAINER.
Other Precautions:FOLLOW LABEL INSTRUCTIONS & WARNINGS.
* Physical/Chemical Properties *
HCC:N1
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR BLUE LIQUID W/MINT FRAGRANCE.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID MIXING W/STRONG OXIDIZERS OR ACIDS.
Stability Condition to Avoid:
* Disposal Considerations *
Waste Disposal Methods:CONSULT STATE, LOCAL, FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ALL RESPS MUST BE NIOSH/MSHA APPROVED. IN OPEN
AREAS W/UNRESTRICTED VENT, A RESP TO REMOVE SOLID AIRBORNE
PARTICLES OF OVERSPRAY MAY BE USED IF PROLONGED/RPTD EXPOS LIKELY.
IN AREAS W/ UNRESTRICTED VE NT THE USE OF CHEM/MECH FILTER(SUPP
DATA
Ventilation:SUPPLY SUFFICIENT VENTILATION TO KEEP AIR CONTAMINANT
CONCENTRATION BELOW CURRENT PEL OR TLV.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING RESTROOM.
Supplemental Safety and Health
RESP PROT:DESIGNED TO REMOVE BOTH PARTICLES AND ORGANIC VAPORS IS
RECOMMENDED.
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 2%
Ingred Name:TITANIUM DIOXIDE
Ingred Name:TOLUENE (SARA III)
Ingred Name:ACETONE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:ANESTHETIC EFFECT. IRRITATION OF
RESPIRATORY TRACT OR ACUTE NERVOUS SYSTEM DEPRESSION CHARACTERIZED
BY HEADACHE, DIZZINESS, STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS
OR COMA. EYE:CONTACT MAY C AUSE REDNESS, IRRITATION, TEARING AND
BLURRED VISION. SKIN:CONTACT MAY DRY SKIN CAUSING CRACKS & (SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:IRRITATION. INGEST:MAY BE HARMFUL OR
FATAL IF SWALLOWED. CHRONIC:REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL EXPOSURE TO SOLVENTS WITH LIVER, KIDNEY,
BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING CONTENTS MAY BE HARMFUL OR
FATAL.
Medical Cond Aggravated by Exposure:ASTHMA AND OTHER RESPIRATORY
AILMENTS. CHEMICAL SENSITIZATION.
* First Aid Measures *
First Aid:INHAL:REMOVE FROM EXPOSURE. GIVE O2 IF NECESSARY. CALL MD.
SKIN:REMOVE CONTAMINATED CLOTHING AND SHOES. WASH CONTACT AREA WITH
SOAP & WATER. WASH CLOTHING AND SHOES BEFORE REUSE. INGEST:DRINK 1
OR 2 GLASSES OF WATER TO DILUTE. INDUCE VOMITING. CALL MD OR POISON
CONTROL CENTER IMMEDIATELY.
* Fire Fighting Measures *
Lower Limits:SEE INGRED
Extinguishing Media:USE (NFPA) CLASS B EXTINGUISHER, CO2 OR FOAM.
Fire Fighting Procedures:FIGHT FIRE FROM A DISTANCE. WEAR NIOSH/MSHA
APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PRESSURE BUILD UP DUE TO HEAT EXPOSURE
MAY CAUSE CONTAINERS TO EXPLODE. WATER MAY BE USED TO COOL RUPTURED
CONTAINERS.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. PROVIDE
VENTILATION. COLLECT SPILLS WITH ABSORBENT MATERIALS AND
NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
NEAR FIRE OR OPEN FLAME. WHEN STORING LARGE QUANTITIES, STORAGE
Other Precautions:PREVENT PROLONGED OR REPEATED BREATHING OF VAPOR OR
SPRAY MIST. DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
USE WITH ADEQUATE VENTILATION.
* Physical/Chemical Properties *
HCC:V3
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE SPRAY WITH SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
UNKNOWN.
Stability Condition to Avoid:HIGH TEMPERATURES AND OPEN FLAMES.
Hazardous Decomposition Products:CO, CO2.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS. DO NOT INCINERATE CONTAINERS.
| 1 | gloves_mandatory |
Control Measures
*
Cage: EPMAR
Proprietary Ind: Y
*
Contractor Summary
*
Cage: 0ZED4
Cage: EPMAR
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:NO SPECIFIC INFO AVAIL. INGEST:CNTNS MATLS THAT MAY
BE SLIGHTLY TOX. INHAL:CNTNS MATLS THAT COULD CAUSE HDCHS, NAUS, DIZZ, &
RESP IRRIT. SENSIT:MAY CAUSE ALLERGIC RESP RESPONSE. SKIN:CNTNS MATLS THAT
MAY CAUSE MOD INJURY (REDDENING &SWELLING). SENSIT:MAY CAUSE ALLERGIC RXN
WHICH CAN BE SEV IN (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZS:CERTAIN INDIVIDUALS. EYE:CNTNS
MATLS THAT MAY CAUSE INJURY WHICH MAY PERSISTS FOR SEVERAL DAYS. CHRONIC:NO
SPECIFIC INFO AVAIL. CNTNS SOLVS WHICH MAY CAUSE INJURY TO LIVER, KIDNEYS,
BONE MAR ROW & BLOOD CELLS AFTER RPTD OVEREXP. CNTNS ING 1 WHICH ARE
REPORTED TO CAUSE LIVER & KIDNEY DMG ON RPTD OVEREXP.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
EYELIDS APART WHILE FLUSING TO RINSE ENTIRE SURF W/WATER. SEEK MED ATTN.
INGEST:IF APPRECIABLE QTYS ARE SWALLOWED, SEEK MED ATTN. INHAL:IN CASE OF
EXPOS TO HIGH CONC OF VAP/MIST, REMOVE TO FRESH AIR. IF BRTHG HAS STOPPED,
ADMIN ARTF RESP & SEEK MED ATTN.
*
Handling and Disposal
*
Spill Release Procedures: AVOID CONT W/MATL. PERSONS NOT WEARING APPROP PROT
EQUIP (SEE CTL MEASURES) SHOULD BE EXCLUDED FROM AREA UNTIL CLEAN-UP IS
COMPLETE. STOP SPILL AT SOURCE, DIKE AREA TO PVTN SPREADING, PUMP LIQ TO SALV
CNTNR. REMAINING LIQ MAY BE TAKEN UP ON (SUP DAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF WASTE IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS. THIS MATERIAL IS NOT DEFINED AS A HAZARDOUS WASTE UNDER
RCRA REGULATIONS.
Handling And Storage Precautions: PVNT ALL SKIN & EYE CONT. AVOID BRTHG
VAPS. RE-SEAL PARTIALLY USED CNTNRS. ENSURE THAT ALL CNTNRS ARE PROPERLY
LBLED TO PVNT ACCIDENTAL INGEST.
Other Precautions: STORE UNDER COOL, DRY CONDITIONS AND AWAY FROM OPEN FLAMES
AND HIGH TEMPERATURES.
*
Fire and Explosion Hazard Information
*
Flash Point Method: SCC
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, WATER FOG AND FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). REMOVE ALL IGNITION SOURCES.
Unusual Fire/Explosion Hazard: COMBUSTIBLE LIQUID-CLASS IIIB. CLOSED CONTAINERS
MAY RUPTURE (DUE TO BUILDUP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
*
*
Respiratory Protection: WHENEVER EXPOS TO VAP/MIST IS LIKELY UNLESS LEVELS ARE
BELOW APPLIC LIMS, WEAR A PROPERLY FITTED NIOSH/MSHA APPRVD RESP. FOR
EMERGENCIES, A NIOSH/MSHA APPRVD SCBA OR FULL FACE RESPIRATOR IS RECOMMENDE
D.
Ventilation: VENT MUST BE SUFFICIENT TO CTL VAPS. BRTHG OF VAPS MUST BE
AVOIDED. THIS MATL SHOULD BE CONFINED AS FAR AS POSS (SUPDAT)
Other Protective Equipment: COVERALLS, APRON & RUB FOOT COVERING AREA REC. SFTY
SHOWER & EYE WASH FACILITY SHOULD BE AVAIL.
Work Hygienic Practices: WASH W/SOAP & WATER BEFORE EATING, DRINKING,
SMKING/USING TOILET FACILITIES. OBSERVE CNDTNS OF GOOD INDUST
Supplemental Safety and Health: USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). SPILL PROC:CLAY, DIATOMACEOUS EARTH/OTHER
ABSORBENT & SHOVELED INTO DISP CNTNRS. VENT:W/IN SEALED/COVERED EQUIP IN
WHICH CASE NO RMAL VENT SHOULD BE ADEQ. SPECIAL (LOC)VENT WILL BE NEEDED IN
AREAS WHERE VAPS ARE EXPECTED TO BE VENTED.
*
Physical/Chemical Properties
*
Evaporation Rate & Reference: SLOWER (BUTYL ACETATE=1)
Appearance and Odor: LIGHT YELLOW LIQUID WITH SLIGHT AMMONIA ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: EXCESSIVE HEAT.
Materials To Avoid: CONTAMINATION WITH STRONG ACIDS, EPOXY RESINS, OR
ISOCYANATES CAN CAUSE REACTION.
Hazardous Decomposition Products: FUMES PRODUCED WHEN HEATED TO DECOMPOSITION
MAY INCLUDE CARBON MONOXIDE, CARBON DIOXIDE, OXIDES OF NITROGEN.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Cage: EPMAR
Company Name: EPMAR CORP
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:INGESTION:CONTAINS MATERIALS THAT
MAY BE SLIGHTLY TOXIC. INHAL:CONTAINS MATERIALS THAT COULD CAUSE HEADACHES,
NAUSEA, DIZZINESS, AND RESPIRATORY IRRITATION. SENSITIZER:MAY CAUSE ALL ERGIC
RESPIRATORY REEACTION. SKIN:CNTNSMATLS THAT MAY CAUSE MOD INJURY (REDDENING
AND SWELLING). SENSITIZER:MAY CAUSE ALLERGIC RXN WHICH CAN BE SEV IN CERTAIN
INDIVIDUALS. EYE:CONTAINS MATLS THAT MAY CAUSE INJURY WHICH MAY PERSIST FOR
SEVERAL DAYS. CHRONIC:CNTNS SOLVS WHICH MAYCAUSE INJURY TO LIVER, KIDNEYS,
BONE MARROW & BLOOD CELLS AFTER RPTD OVEREXP. CNTNS POLYETHYLENE
POLAMINES WHICH ARE REPOR TED TO CAUSE LIVER & KIDNEY DMG ON RPTD
OVEREXP.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE SELF-CONTAINED BREATHING APPARATUS IN HIGH
VAPOR CONCENTRATION.
Ventilation:SPEFCIAL, LOCAL VENTILATION IS NEEDED WHERE VAPORS ESCAPE
TO THE WORKPLACE AIR.
Other Protective Equipment:LAB COAT OR UNIFORM, EYE WASH, SAFETY SHOWER
Work Hygienic Practices:WASH THOROUGHLY HAFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ETHANOL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Health Hazards Acute and Chronic:TARGET ORGANS: CNS, RESPIRATORY TRACT,
EYES. INGESTION MAY CAUSE DIZZINESS, FAINTNESS, DROWSINESS,
DECREASED AWARENESS OR RESPONSIVENESS, NAUSEA, VOMITING, STAGGERING
GAIT, LACK OF CO-ORDINATION, COMA . INHALATION MAY CAUSE BURNING
SENSATIONOF NOSE & THROAT, STINGING, WATERING OF EYES; AT WHICH
CAUSE IRRITATION, DIZZINESS, FAINTNESS, DROWSINESS, NAUSEA &
VOMITING MAY ICCUR. EYE CONTACT MAY CAUSE ST ING, TEARING &
REDNESS. CHRONIC: LONG TERM REPEATED ORAL EXPOSURE TO ETHANOL MAY
RESULT IN PROGRESSIVE LIVER INJURY WITH FIBROSIS.
Explanation of Carcinogenicity:NOT CLASSIFIABALE AS A HUMAN CARCINOGEN.
Effects of Overexposure:INGESTION MAY CAUSE DIZZINESS, FAINTNESS,
DROWSINESS, DECREASED AWARENESS OR RESPONSIVENESS, NAUSEA,
VOMITING, STAGGERING GAIT, LACK OF CO-ORDINATION, COMA. INHALATION
MAY CAUSE BURNING SENSATION OF N OSE & THROAT, STINGING, WATERING
OF EYES; AT WHICH CAUSE IRRITATION, DIZZINESS, FAINTNESS,
DROWSINESS, NAUSEA & VOMITING MAY ICCUR. EYE CONTACT MAY CAUSE
STING, TEARING & REDNESS.
Medical Cond Aggravated by Exposure:REPEATED EXPOSURE TO ETHANOL MAY
AGGRAVATE LIVER INJURY PRODUCED FROM OTHER CAUSES.
* First Aid Measures *
First Aid:INGESTED-IF CONSCIOUS, GIVE 2 GLASSES WATER, INDUCE VOMITING.
OBTAIN MEDICAL ATTENTION. SKIN-WASH WITH SOAP & WATER FOR AT LEAST
MINUTES. INHALED-REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION
IF NO T BREATHING. GIVE OXYGEN IF BREATHING DIFFICULT. EYES: FLUSH
WHEN BLOOD ALCOHOL LEVELS REACH 0.3-0.5%. ABOVE 0.5% THE PERSON
WILL BE COMATOSE. AND DEATH CAN OCCUR.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:3.3
Extinguishing Media:APPLY ALCOHOL-TYPE OR ALL-PURPOSE FOAM BY
MANUFACTURER'S RECOMMENDED TECHNIQUES FOR LARGE FIRES. USE CARBON
DIOXIDE OR DRY CHEMICAL MEDIA FOR SMALL FIRES.
Fire Fighting Procedures:USE WATER SPRAY TO COOL FIRE-EXPOSED
CONTAINERS AND STRUCTURES. USE WATER SPRAY TO DISPERSE
VAPORS-RE-IGNITION IS POSSIBLE; USE SELF-CONTAINED BREATHING
APPARATUS AND PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS MAY TRAVEL TO SOURCE OF IGNITION
AND FLASH BACK. VAPORS MAY SETTLE IN LOW OR CONFINED SPACES. MAY
PRODUCE A FLOATING FIRE HAZARD. STATIC IGNITION HAZARD CAN RESULT
FROM HANDLING AND USE.
* Accidental Release Measures *
Spill Release Procedures:SMALL SPILLS CAN BE FLUSHED WITH LARGE AMOUNTS
OF WATER. LARGE SPILL: ELIMINATE ALL IGNITION SOURCES; GROUND ALL
EQUIPMENT; DO NOT WALK THROUGH SPILL; STOP SPILL IF POSSIBLE;
PREVENT ENTRY INTO SEWERS , CONFINDED SPACES, ETC. USE A VAPOR
SUPPRESSING FOAMTO REDUCE VAPORS. ABSORB WITH NON-COMBUSTIBLE
MATTER & TRANSFER TO CONTAINERS, USE NON-SPARKING TOOLS TO COLLECT
ABSORBED MATERIAL.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS &
FLAME.SUDDEN RELEASES OF HOT ORGANIC VAPORS OR MISTS FROM PROCESS
EQUIPMENT OPERATING AT ELEVATED TEMPERATURE MAY RESULT IN IGNITIONS
WITHOUT THE PRESENCE OF OBVIOUS SOUR CES.KEEP CONTAINER CLOSED.USE
WITH ADEQUATE VENTILATION.GROUND CONTAINERS WHEN TRANSFERRING
PRODUCT.
Other Precautions:AVOID CONTACT WITH EYES. VAPORS MAY COLLECT IN
CONTAINERS; TREAT EMPTY CONTAINERS AS HAZARDOUS. WASH THOROUGHLY
AFTER HANDLING.
* Physical/Chemical Properties *
HCC:F2
Vapor Density:1.6
Evaporation Rate & Reference:3.3 (BUTYL ACETATE=1)
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH CHARACTERISTIC ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS; STRONG INORGANIC ACIDS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:CARBON MONOXIDE AND/OR CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Toxicological Information*
Toxicological Information:REPEATED INGESTION OF ETHANOL BY PREGNANT
MOTHERS HAS BEEN SHOWN TO ADVERSELY AFFECT THE CENTRAL NERVOUS
SYSTEM OF THE FETUS, PRODUCING A COLLECTION OF EFFECTS WHICH
TOGETHER CONSTITUTE FETAL ALCOHOL SYNDROME. THESE INCLUDE MENTAL &
PHYSICAL RETARDATION, DISTURBANCES OF LEARNING, MOTOR AND LANGUAGE
DEFICIENCIES, BEHAVIORAL DISORDERS AND SMALL SIZE HEAD.
* Ecological Information *
Ecological:
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF SPILL-CLAEN UP AND OTHER WASTES IN
ACCORDANCE WITH FEDERAL, STATE & LOCAL REGULATIONS.
* MSDS Transport Information *
Transport Information:PROPER SHIPPING NAME: ETHYL ALCOHOL; HAZARD
SOLUTIONS; LABEL OF CLASS: 3; PACKING GROUP II; INTERMEDIATE
FLASHPOINT GROUP.
* Regulatory Information *
PRESENT WHICH REQUIRE REPORTING UNDER THIS STATUTE: NONE.
OF SARA III: NONE.
Federal Regulatory Information:TSCA: THE INGREDIENTS OF THIS PRODUCT
ARE ON THE TSCA INVENTORY. CERCLA REQUIRES NOTIFICATION OF THE
NATIONAL RESPONSE CENTER OF RELEASE QUANTITIES OF HAZARDOUS
SUBSTANCES EQUAL TO OR GREATER THATN TH E REPORTABLE QUANTITIES
(RQ) IN CFR. COMPONENTS PRESENT IN THIS PRODUCT AT A LEVEL WHICH
CONTAINS TRACE LEVELS OF ACETALDEHYDE KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANER. MASSACHUTTES:HAZARDOUS SUBSTANCES AND
EXTRAORDINARILY HAZARDOUS SUBSTANCES MUST BE IDENTIFIED.
COMPONENTS PRESENTWHICH COULD REQUIRE REPORTING: EXTRAORDINARILY
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN OUTDOOR/OPEN AREAS, USE NIOSH/MSHA APPROVED
MECHANICAL FILTER RESPIRATOR DURING SPRAY APPLICATION. IN
RESTRICTED AREAS, USE NIOSH/MSHA APPROVED CHEMICAL MECHANICAL
FILTERS. IN CONFINED AREAS, USE N IOSH/MSHA AIR LINE TYPE
RESPIRATOR/HOODS
Ventilation:GENERAL DILUTION/LOCAL EXHAUST TO KEEP TLV < ACCEPTABLE
LIMIT.
Other Protective Equipment:APRON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
AVOID CONTACT W/EYES & SKIN. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE CONTENTS MAY BE HARMFUL/FATAL. THIS
PRODUCT CONTAINS PIGMENTS WHICH MAY BECOME A DUST NUISANCE WHEN
REMOVED BY ABRASIVE BLASTING, SANDING/GRINDING.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:V M & P NAPHTHA, LIGROINE, MINERAL SPIRITS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT MAY CAUSE NOSE, THROAT & EYE
IRRITATION. MINERAL SPIRITS IS A CNS DEPRESSANT & A MUCOUS MEMBRANE
IRRITANT. REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE
PERMANENT BRAIN & NERVOUS SYSTE M DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, HEADACHE, INTOXICATION
W/EUPHORIA, UNCONSCIOUSNESS.
* First Aid Measures *
W/COPIOUS AMOUNTS OF LUKE WARM WATER. INHALATION: REMOVE TO FRESH
AIR. RESTORE BREATHING IF REQUIRED. INGESTION: RINSE MOUTH
IMMEDIATELY. GI VE 6-8 OUNCES OF LIQUID. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON. DON'T INDUCE VOMITING UNLESS
ADVISED BY A PHYSICIAN. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:<0.9
Upper Limits:>7
Extinguishing Media:WATER SPRAY, WATER, FOG NOZZLES, NFPA CLASS B
EXTINGUISHER.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE . WATER MAY BE
USED TO COOL CLOSED CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINER MAY EXPLODE WHEN EXPOSED
TO EXTREME HEAT. NEVER USE WELDING/CUTTING TORCH ON/NEAR CONTAINER
BECAUSE PRODUCT MAY IGNITE EXPLOSIVELY.
* Accidental Release Measures *
Spill Release Procedures:STOP &/CONTAIN DISCHARGE SAFELY. KEEP SOURCES
OF IGNITION AWAY. VENITLATE AREA. USE NON-SPARKING TOOLS FOR
CLEANUP. COVER W/INERT MATERIAL TO REDUCE FUMES. KEEP OUT OF
DRAINS, SEWERS/WATERWAYS. NOTIFY LOCAL HEALTH & POLLUTION CONTROL
AGENCIES.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED WHEN NOT
IN USE. USE ONLY W/ADEQUATE VENTILATION. DON'T CUT/PUNCTURE
CONTAINER.
Other Precautions:GROUND COTAINERS WHEN POURING & LIMIT FREE FALL TO A
FEW INCHES TO PREVENT STATIC SPARKS. AVOID SPONTANEOUS COMBUSTION
OF CONTAMINATED RAGS/OTHER EASILY IGNITABLE ORGANIC MATERIALS BY
IMMERSION IN WAT ER. KEEP OUT OF REACH OF CHILDREN.(SUPP)
* Physical/Chemical Properties *
Vapor Pres:2
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN BU AC
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE W/STRONG ACIDS.
Stability Condition to Avoid:SPARKS, OPEN FLAME, HOT SURFACES & OTHER
SOURCES OF IGNITION.
Hazardous Decomposition Products:WHEN HEATED: CO, CO2 & OXIDES OF
NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:DON'T FLUSH TO SEWER, WATERSHED/WATERWAY.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS. DON'T INCINERATE
CLOSED CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED ORGANIC VAPOR
SELECTION.
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION IS NORMALLY ADEQUATE.
LOCAL EXHAUST MAY BE REQUIRED IF WORK AREA NOT VENTED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
* Product Identification *
Product ID:CHROMIC ACID-FLAKE
Preparer's Name:B. L. GRAHAM
* Composition/Information on Ingredients *
Ingred Name:CHROMIC ACID (CHROMIUM TRIOXIDE)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALING DUST OR MIST MAY CAUSE
IRRITATION OF THE NASAL SEPTUM AND RESPIRATORY TRACT. SKIN CONTACT
MAY CAUSE SEVERE BURNS. MODERATE IRRITATION OR CONJUNCTIVITIS OF
THE EYES. INGESTION MAY CAUSE SEVERE TISSUE DESTRUCTION. CHRONIC:
ULCERATION AND PERFORATION OF THE NASAL SEPTUM, KIDNEY FAILURE AND
DEATH.
Explanation of Carcinogenicity:NTP AND IARC HAVE DETERMINED THAT THERE
IS SUFFICIENT EVIDENCE FOR THE CARCINOGENICITY OF HEXAVALENT
CHROMIUM COMPOUNDS.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
* Fire Fighting Measures *
Lower Limits:NOT APPLICAE
Upper Limits:NOT APPLICAE
Extinguishing Media:PRODUCT IS NOT COMBUSTIBLE. WATER FOG, DRY CHEMICAL
OR CARBON DIOXIDE MAY BE USED IN AREAS WHERE PRODUCT IS STORED.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:UNDER FIRE CONDITIONS, DECOMPOSING
MATERIAL MAY FORM A HOT VISCOUS FOAM. OXIDIZER. AVOID CONTACT WITH
ORGANIC MATERIALS.
* Accidental Release Measures *
Spill Release Procedures:STOP LEAKS. REMOVE AS MUCH AS POSSIBLE (E.G.
VACUUM TRUCK). THEN TREAT THE SPILL AREA WITH A REDUCING AGENT TO
CONVERT THE HEXAVALENT CHROMIUM TO THE TRIVALENT FORM AND
NEUTRALIZE WITH A WEAK BASE. SO AK UP AND PROPERLY STORE. DO NOT
FLUSH TO SEWER.
Neutralizing Agent:SODIUM BICARBONATE, SODA ASH OR LIME. REDUCE WITH
SODIUM BISULFITE, OR OTHERS.
*Handling and Storage *
Handling and Storage Precautions:DO NOT STORE IN CLOSE PROXIMITY TO
COMBUSTIBLE MATERIALS. STORE IN TIGHTLY CLOSED CONTAINERS AWAY FROM
SOURCES OF HEAT.
Other Precautions:REDUCE WITH SODIUM BISULFITE, SODIUM SULFITE, FERROUS
SULFATE OR FERROUS CHLORIDE. NEUTRALIZE TO A PH 7.5 WITH SODA ASH,
CAUSTIC SODA OR LIME TO FORM A PRECIPITATE.
* Physical/Chemical Properties *
HCC:D1
Spec Gravity:2.7
pH:0.2-2
Appearance and Odor:SOLID DARK RED FLAKES OR POWDER; NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH ORGANIC MATERIALS, OILS, GREASES, OR ANY EASILY
OXIDIZABLE MATERIAL. PRODUCT IS HYGROSCOPIC.
Stability Condition to Avoid:UNDER NORMAL USE CONDITIONS, THIS PRODUCT
IS STABLE.
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. IF IN
SOLUTION, MUST BE REDUCED TO TRIVALENT CHROMIUM FIRST AND THEN
NEUTRALIZED TO FORM PRECIP ITANT.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
ONLY NIOSH/MSHA APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING,
ESPECIALLY BEFORE EATING OR SMOKING.
Supplemental Safety and Health
MEDICAL TREATMENT IMMEDIATELY. OTHER PREC:APPROVED RESPIRATORY
PROTECTION AS DIRECTED. AVOID CONTACT WITH SKIN AND EYES, AND BRE
ATHING OF VAPORS. EXPLANATION OF CARCINOGENICITY: SIXTH ANNUAL
* Product Identification *
Product ID:SPRED ULTRA EXTERIOR GLOSS LATEX HOUSE AND
* Composition/Information on Ingredients *
Fraction by Wt: 1-5%
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:PROPANOIC ACID, 2-METHYL-, MONOESTER WITH
Fraction by Wt: 1-5%
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (QUARTZ)
Fraction by Wt: <1.0%
OSHA PEL:SEE TABLE Z3
Ingred Name:C.I. PIGMENT GREEN 7; (PHTHALOCYANINE GREEN)
Fraction by Wt: 1-5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:IRRIT OF RESP TRACT. SKIN:IRRIT.
PRLNGD/RPTD CONT CAN CAUSE DERM. MAY BE ABSORBED THROUGH SKIN.
EYES:IRRIT. INGEST:MAY CAUSE VOMIT, DIARR, CNS DEPRESS, KIDNEY DMG.
PRODS IN THIS SERIES CONTAIN C RYSTALLINE SILICA, WHICH IS
CONSIDERED A HAZ BY INHAL. CRYSTALLINE SILICA IS ALSO A KNOWN CAUSE
OF (EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE - QUARTZ:GROUP 2A,
NTP (SUP DATA)
Effects of Overexposure:HLTH HAZ:SILICOSIS, A NONCANCEROUS LUNG
DISEASE. PROD IN THIS SERIES CONTAIN ETHYLENE GLYCOL WHEN TINTED
W/DRAMATONE. ETHYLENE GLYCOL CAN CAUSE SEV KIDNEY DMG WHEN INGEST
AND HAS BEEN SHOWN TO CAUSE B IRTH DEFECTS IN LAB ANIMALS.
Medical Cond Aggravated by Exposure:INGREDIENTS CONTAINED IN THESE
PRODUCTS HAVE BEEN REPORTED TO AGGRAVATE PREEXISTING EYE, SKIN,
RESPIRATORY, LUNG AND KIDNEY DISORDERS.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET EMERG MED ATTN. HAVE TRAINED PERSON GIVE OXYGEN IF NEC. GET MD
HELP FOR ANY BRTHG DFCLTY. SKIN:WASH OFF QUICKLY W/PLENTY OF WATER,
THE N SOAP & WATER. REMOVE CONTAM CLTHG. WASH CONTAM CLTHG BEFORE
REUSE. EYE:FLUSH IMMED W/LRG AMTS OF WATER, ESP UNDER LIDS, FOR AT
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:SEE ING 1&3
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WATER MAY BE USED TO COOL AND PROTECT
EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE.
* Accidental Release Measures *
Spill Release Procedures:COMPLY WITH ALL APPLICABLE HEALTH AND
ENVIRONMENTAL REGULATIONS. VENTILATE AREA. SPILL MAY BE COLLECTED
WITH ABSORBENT MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
USE ONLY WITH ADEQUATE VENTILATION. DO NOT TAKE INTERNALLY. KEEP
OUT OF REACH OF CHILDREN.
Other Precautions:KEEP CONTS TIGHTLY CLSD & UPRIGHT WHEN NOT IN USE.
AVOID CONDITIONS WHICH RESULT IN FORMULATION OF INHALABLE PARTICLES
SUCH AS SPRAYING/ABRADING (SANDING) PAINTED SURF. IF SUCH
CONDITIONS CANNOT BE AV OIDED, USE APPROP NIOSH/MSHA (SUPDAT)
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ALUMINUM, ZINC, METALS, ACIDS, ALCOHOLS, MAGNESIUM, SODIUM,
POTASSIUM.
Stability Condition to Avoid:ELEVATED TEMPERATURES, CONTACT WITH
OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS. DISCHARGE TO NATURAL WATERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:LOCAL/MECHANICAL EXHAUST ACCEPTABLE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:GENERALLY GOOD PLANT HYGENIC PRACTICES
ACCEPTABLE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:TRUBBLE BUBBLE HL-7
* Composition/Information on Ingredients *
ALKYL ETHERS
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO ADVERSE HEALTH AFFECTS HAVE BEEN
OBSERVED FOR THIS PRODUCT IN NORMAL USAGE. (MFR)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:
Medical Cond Aggravated by Exposure:CAN CAUSE EYE IRRITATION.
* First Aid Measures *
First Aid:EYES:FLUSH WITH COPIOUS AMOUNTS OF WATER. SEE MD IF
IRRITATION PERSISTS. INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING
(O*2/ARTIFICIAL RSP) SEE MD. INGEST:SEE MD IMMEDIATELY .
* Fire Fighting Measures *
Extinguishing Media:WATER, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:WASH WITH WATER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT WITH CATIONIC MATERIALS.
Other Precautions:AVOID CONTACT WITH EYES, MILD IRRITANTS.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:>1
Solubility in Water:COMPLETE
Appearance and Odor:GREENISH BLUE LIQUID, MILD ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CATIONIC SURFACTANT, OXIDIZING AND REDUCING AGENTS
Stability Condition to Avoid:
Hazardous Decomposition Products:CARBON DIOXIDE, NITROGEN OXIDES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE I/A/W FEDERAL, STATE, AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT PROVIDED BY MANUFACTURER
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. WASH
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NOT PROVIDED BY MANUFACTURER
* Product Identification *
CAGE:1FPM8
CAGE:1FPM8
* Composition/Information on Ingredients *
Ingred Name:2-MERCAPTOBENZOTHIAZOLE
* Hazards Identification *
Health Hazards Acute and Chronic:TO THE BEST OF OUR KNOWLEDGE, THE
CHEMICAL, PHYSICAL, AND TOXICOLOGICAL PROPERTIES HAVE NOT BEEN
THOROUGHLY INVESTIGATED. EXPOSURE CAN CAUSE: HARMFUL IF SWALLOWED,
INHALED, OR ABSORBED THROUGH SKIN.
Explanation of Carcinogenicity:TUMORIGENIC (CARCINOGENIC) BY RTECS
CRITERIA.
Effects of Overexposure:EXPOSURE CAN CAUSE: HARMFUL IF SWALLOWED,
INHALED, OR ABSORBED THROUGH SKIN.
Medical Cond Aggravated by Exposure:MAY CAUSE ALLERGIC RESPIRATORY AND
SKIN REACTIONS.
* First Aid Measures *
First Aid:IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES OR SKIN WITH
CONTAMINATED CLOTHING AND SHOES. IF INHALED, REMOVE TO FRESH AIR.
IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. ASSURE ADEQUATE FLUSHING OF THE EYES BY
SEPARATING THE EYELIDS WITH FINGERS.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR APPROPRIATE
FOAM.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:WEAR SELF CONTAINED BREATHING APPARATUS,
HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. STORE IN A COOL
DRY PLACE.
Other Precautions:DO NOT BREATHE DUST. AVOID PROLONGED OR REPEATED
EXPOSURE. DO NOT GET IN EYES, ON SKIN, ON CLOTHING. TOXIC.
SENSITIZER.
* Physical/Chemical Properties *
HCC:T6
Appearance and Odor:DULL-YELLOW POWDER
* Stability and Reactivity Data *
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE
* Toxicological Information*
Toxicological Information:ACUTE EFFECTS:TO THE BEST OF OUR
KNOWLEDGE,THE CHEMICAL,PHYSICAL & TOXICOLOGICAL PROPERTIES HAVE NOT
BEEN THOROUGHLY INVESTIGATED.EXPOSURE CAN CAUSE:HARMFUL IF
SWALLOWED,INHALED OR ABSORBED THROUGH SK IN.MAY CAUSE ALLERGIC
MG/KG.TARGET ORGAN DATA:BEHAVIORAL (SOMNOLENCE);BEHAVIORAL
(CONVULSIONS);BLOOD (TUMORS);EFFECTS ON FERTILITY
(POST-IMP[LANTATION MORTALITY);EFFECTS ON EMBYO OR FETUS
(FETOTOXICITY); EFFECTS ON EMB RY OR FETUS (FETAL DEATH).
* Ecological Information *
Ecological:DATA NOT YET AVAILABLE.
* Disposal Considerations *
Waste Disposal Methods:
* MSDS Transport Information *
Transport Information:CONTACT ALDRICH CHEMICAL COMPANY FOR
TRANSPORTATION INFORMATION.
* Regulatory Information *
REPORTING REQUIREMENTS.
Federal Regulatory Information:EPA TSCA 8(B) CHEMICAL INVENTORY, EPA
PESTICIDE SUBJECT TO REGISTRATION OR RE-REGISTRATION.
State Regulatory Information:
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A NIOSH APPROVED PARTICULATE RESPIRATOR
WHENEVER DUST MAY BE DETECTED INTO THE AIR.
Ventilation:ADEQUATE LOCAL EXHAUST VENTILATION TO KEEP BELOW TLV
Other Protective Equipment:SAFETY FOOTWEAR
Work Hygienic Practices:CHANGE CLOTHING DAILY IF IT IS CONTAMINATED
W/PRODUCT OR ITS BY-PRODUCTS. WASH HANDS THOROUGHLY & OFTEN AFTER
HANDLING.
Supplemental Safety and Health
* Product Identification *
CAGE:0VMB9
CAGE:0VMB9
* Composition/Information on Ingredients *
Ingred Name:ALUMINUM OXIDE, BAUXITE, ALUMINA, DIALUMINUM TRIOXIDE
Ingred Name:AMMONIUM CHLORIDE
Fraction by Wt: 0-5%
Ingred Name:AMMONIUM FLUORIDE
Fraction by Wt: 0-5%
OSHA PEL:2.5MG/CUM
ACGIH TLV:2.5MG/CUM
Ingred Name:ALUMINUM (POWDER)
Ingred Name:TRADE SECRET COMPONENT
Fraction by Wt: 0-5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE IRRITATION. DERMATITIS. CAUSES
BURNS ON CONTACT. RESPIRATORY IRRITATION. TOXIC BY
INGESTION/INHALATION. GASTROENTERITIS, VASOMOTOR DEPRESSION,
CARDIAC DISTURBANCE, OSSEOUS FLUOROSIS, CONVULSIONS, VASCULAR
COLLAPSE. PULMONARY EDEMA. INJURY TO LIVER OR KIDNEYS. CONTRIBUTION
TO SHAVERS DISEASE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE IRRITATION. NAUSEA. CONVULSIONS. RASH,
SHORTNESS OF BREATH.
* First Aid Measures *
First Aid:EYES: FLUSH W/PLENTY OF WATER. SKIN: FLUSH W/SOAP & WATER. IF
PRODUCT IS BENEATH CLOTHING, REMOVE THE CLOTHING & FLUSH W/WATER.
INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED PERFORM
CPR. K EEP PERSON WARM & AT REST. INGESTION: OBTAIN MEDICAL
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:CLASS D FIRE EXTINGUISHER, WATER FOG OR SPRAY,
WATER, FOAM, OR DRY CHEMICAL.
Unusual Fire/Explosion Hazard:FINELY DIVIDED DUST MAY IGNITE WHEN IN
CONTACT W/A FLAME.
* Accidental Release Measures *
Spill Release Procedures:USE PROTECTIVE EQUIPMENT. COLLECT MATERIAL BY
DRY SWEEPING.
*Handling and Storage *
Handling and Storage Precautions:KEEP PRODUCT DRY & IN CLOSED
CONTAINERS. DON'T STORE NEAR MINERAL ACIDS.
Other Precautions:KEEP WORK AREA CLEAN. DON'T EAT OR DRINK IN WORK
AREAS. WEAR PROTECTIVE CLOTHING AT ALL TIMES.
* Physical/Chemical Properties *
HCC:N1
Appearance and Odor:GRAY SOLID, NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS & ACIDS
Stability Condition to Avoid:ELEVATED & EXTREME TEMPERATURES
Hazardous Decomposition Products:MAY FORM OZONE/NITRIC OXIDE BY PLASMA
FLAME, REACTION W/HYDROGEN CYANIDE MAY GIVE NITROGEN TRICHLORIDE,
-HF, NH3.
* Disposal Considerations *
Waste Disposal Methods:SALVAGE MATERIAL FOR ON-SITE REUSE OR RECYCLING.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
Ventilation:USE PROCESS ENCLOSURE OR LOCAL EXHAUST TO MAINTAIN EXPOSURE
BELOW TLV(S).
Other Protective Equipment:WEAR APPROPRIATE PROTECTIVE CLOTHING TO
PREVENT SKIN EXPOSURES.I
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
ENGINEERING CONTROLS: USE ADEQUATE VENTILATION OR LOCAL EXHUAST
VENTILATION TO KEEP AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE
EXPOSURE LIMITS.
* Product Identification *
Product ID:MERCURY
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C, 0.1 MG/M3; Z-2
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE-MAY CAUSE SEVERE IRRITATION &
POSSIBLE EYE BURNS. VAPORS MAY CAUSE EYE IRRITATION. SKIN-MAY CAUSE
SKIN IRRITATION. INGESTION-MAY CAUSE GASTROINTESTINAL IRRITATION.
INHALATION-CAUSES RESPIRATORY TR ACT IRRITATION. INHALATION OF
FUMES MAY CAUSE METAL FUME FEVER. MAY CAUSE CENTRAL NERVOUS SYSTEM
EFFECTS. CHRONIC: CHRONIC EXPOSURE TO MERCURY MAY CAUSE CENTRAL
NERVOUS SYSTEM DAMAGE, FATIGUE, WEIGHT LOSS, TREMORS, PEROSNALITY
CHANGES.
Explanation of Carcinogenicity:MERCURY IS LISTED BY IARC AS A GROUP 3
(INSUFFICIENT EVIDENCE) CARCINOGEN.
Effects of Overexposure:SKIN-CHRONIC EXPOSURE TO MERCURY MAY CAUSE
PERMANENT CENTRAL NERVOUS SYSTEM DAMAGE, FATIGUE, WEIGHT LOSS,
TREMORS, PEROSNALITY CHANGES. INGESTION-MAY CAUSE NAUSEA, VOMITING
AND DIARRHEA. INHALATION-MA Y CAUSE FLU-LIKE SYMPTOMS WITH METALLIC
TASTE, FEVER, CHILLS, COUGH, WEAKNESS, CHEST PAIN, MUSCLE PAIN AND
INCREASED WHITE BLOOD CELL COUNT. MAY CAUSE VERTIGO, ANXIETY,
DEPRESSION, MUSCLE INCOORDINATI ON AND EMOTIONAL INSTABILITY.
* First Aid Measures *
OCCASIONALLY LIFTING THE UPPER & LOWER LIDS. GET MEDICAL AID
IMMEDIATELY. SKIN-GET MEDICAL AID. IMMEDIATELY FLUSH SKIN WITH
BY MOUTH TO AN UNCONSCIOUS PERSON. GET MEDICAL AID IMMEDIATELY.
WASH MOUTH OUT WITH WATER. INHALATION-REMOVE FROM EXPOSURE TO FRESH
AIR IMMEDIATELY. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL AID. NOTE TO
PHYSICIAN: TREAT SYMPTOMATICALLY AND SUPPORTIVELY.
* Fire Fighting Measures *
Extinguishing Media:SUBSTANCE IS NONFLAMMABLE, USE AGENT MOST
APPROPIATE TO EXTINGUISH SURROWATER FOG, CARBON DIOXIDE, DRY
CHEMICAL, FOAM. USE MEDIA APPROPRIATE FOR SURROUNDING FIRE IN
FLOODING AMOUNTS.
Fire Fighting Procedures:AS AN ANY FIRE, WEAR A SELF CONTAINED
BREATHING APPARATUS IN PRESSURE-DEMAND. MSHA/NIOSH (APPROVED OR
EQUIVALENT), AND FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:COMBUSTION GENERATES TOXIC FUMES.
* Accidental Release Measures *
Spill Release Procedures:VACUUM OR SWEEP UP MATERIAL & PLACE INTO
SUITABLE DISPOSAL CONTAINER. WEAR A SELF CONTAINED BREATHING
APPARATUS & APPROPIATE PERSONAL PROTECTION
*Handling and Storage *
Handling and Storage Precautions:WASH THOROUGHLY AFTER HANDLING REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE. USE WITH ADEQUATE
VENTLATION. MINIMIZE DUST GENERATION AND ACCOMULATION. AVOID
BREATHING DUST, VAPOR, MIST, OR GAS. A VOID CONTACT WITH EYES, SKIN
AND CLOTHING. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:ANTIDOTE: THE USE OF D-PENICILLAMINE AS A CHELATING
AGENT SHOULD BE DETERMINED BY QUALIFIED MEDICAL PERSONNEL. THE USE
OF DIMERCAPROL OR BAL (BRITISH ANTI-LEWISITE) AS A CHELATING AGENT
SHOULD BE DETE RMINED BY QUALIFIED MEDICAL PERSONNEL.
* Physical/Chemical Properties *
HCC:Z2
Vapor Density:7.0
Solubility in Water:INSOLUBLE
Appearance and Odor:LIQUID, SILVER, ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACETYLENE, AMMONIA, BORON, PHOSPHODIPHRIDE, CHLORINE CHLORINE DIOXIDE,
METHYL AZIDE, SODIUM CARBIDE, HALOGENS, STRONG OXIDIZERS.
Stability Condition to Avoid:STABLE UNDER NORMALTEMPERATURES AND
PRESSURES. HIGH TEMPERATURES, INCOMPATIBLE MATERIALS, METALS.
Hazardous Decomposition Products:MERCURY AND MERCURY OXIDES.
Conditions to Avoid Polymerization:HAS NOT BEEN REPORTED.
* Toxicological Information*
CLASSIFIED AS A HUMAN CARCINOGEN. IARC: GROUP 3 CARCINOGEN LISTED
AS MERCURY, ARYL AND INORGANIC.
* Ecological Information *
BIOCONCENTRATE IN A QUATIC ORGANISMS. ON SOIL, SUBSTANCE IS SUSPECT
TO VOLITILIZE RAPIDLY. IN WATER SUBSTANCE BINDS TO PARTICULATES &
COLLECTS IN THE SEDIMENTS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE & LOCAL REGULATIONS. RCRA D-SERIES MAXIMUM CONCENTRATION OF
0.2 MG/L. RCRA D-SE RIES CHRONIC TOXICITY REFERENCE LEVELS: CAS#
* MSDS Transport Information *
Transport Information:US DOT: SHIPPING NAME: RQ, MERCURY. HAZARD CLASS:
* Regulatory Information *
INVENTORY.
State Regulatory Information:CALIFORNIA, NEW JERSEY, FLORIDA,
PENNSYLVANIA, MINNESOTA, MASSACHUSETTS.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:APPROPRIATE VAPOR CANISTER, SELF-CONTAINED
BREATHING APPARATUS OR AIR-SUPPLIED HOSE MASK, IF NEEDED.
Ventilation:SUFFICIENT, IN VOLUME AND PATTERN, TO KEEP WORKROOM
EXPOSURE BELOW CURRENT APPLICABLE OSHA REQUIREMENTS. USE EXPLOSION
PROOF EQUIPMENT. NO SMOKING.
Other Protective Equipment:IMPERVIOUS CLOTHING OR BOOTS, IF NEEDED.
Work Hygienic Practices:KEEP AWAY FROMHEAT, SPARKS AND OPEN FLAME.
KEEP CONTAINERS CLOSED WHEN NOT IN USE. AVOID EYE CONTACT. AVOID
PROLONGED OR REPEATED CONTACT WITH SKIN. WASH SKIN WITH SOAP AND
WATER AFTER CONTACT.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MINERAL SPIRITS
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: MAY CAUSE IRRITATION,
REDNESS, SWELLING OF EYES. SKIN CONTACT: LIQUID IS SLIGHTLY
IRRITATING. PROLONGED OR REPEATED CONTACT CAN RESULT IN DEFATTING
AND DRYING WHICH MAY RESULT IN IRRITAT ION AND DERMITITIS.
INHALATION: VAPORS MAY CAUSE IRRITATION TO NOSE, THROAT,
RESPIRATORY TRACT. BREATHING HIGH VAPOR CONCENTRATIONS MAY RESULT
IN HEADACHESS, DIZZINESS, OTHER SIGNS OF NERVOUS SYSTEM D
EPRESSION. WHEN USED IN REASONABLE MANNER, NO ADVERSE EFFECTS
ANTICIPATED FROM EXPOSURE TO THIS PRODUCT. INGESTION: MAY RESULT IN
VOMITING, ASPIRATION OF VOMITUS MUST BE AVOIDED AS EVEN SMALL
QUANTITI ES MAY RESULT IN ASPIRATION PNEUMONITIS.
Explanation of Carcinogenicity:THIS PRODUCT HAS NOT BEEN IDENTIFIED AS
A CARCINOGEN BY NTP, IARC, OR OSHA.
Effects of Overexposure:EYES: IRRITATION, REDNESS, SWELLING OF EYES.
SKIN: IRRITATI0N, DEFATTING, DRYING, DERMITITIS. INHALATION:
IRRITATION OF NOSE, THROAT, RESPIRATORY TRACT, HEADACHESS,
DIZZINESS, OTHER SIGNS OF NERVOUS S YSTEM DEPRESSION. WHEN USED IN
A REASONABLE MANNER, NO ADVERSE EFFECTS ARE ANTICIPATED FROM
EXPOSURE TO THIS PRODUCT.
Medical Cond Aggravated by Exposure:REPEATED SKIN CONTACT MAY AGGRAVATE
AN EXISTING DERMATITIS CONDITION. SKIN DISORDER AND RESPIRTORY
(ASTHMA-LIKE) DISORDERS MAY BE AGGRIVATED BY EXPOSURE TO THIS
PRODUCT..
* First Aid Measures *
WHILE HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION.SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING/SHOES. FLUSH SKIN WITH WATER. FOLLOW
BY WASHI NG WITH SOAP AND WATER. IF IRRITATION OCCURS, GET MEDICAL
ATTENTION. DO NOT REUSE CLOTHING UNTIL CLEANED. INHALATION: MOVE
VICTIM TO FRESH AIR AND PROVIDE OXYGEN IF BREATHING IS DIFFICULT.
GIVE ARTIFI CIAL RESPIRATION IF NOT BREATHING. INGESTION: DO NOT
INDUCE VOMITING. IF VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD BELOW
HIPS TO PREVENT ASPIRATION OF LIQUID INTO THE LUNGS. GET MEDICAL
ATTENTION.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.9
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL, WATER SPRAY. DO
NOT USE DIRECT WATER STREAM; IT WILL SPREAD FIRE.
Fire Fighting Procedures:USE AIR-SUPPLIED RESCUE EQUIPMENT FOR ENCLOSED
AREAS. COOL EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:DO NOT STORE OR MIX WITH STRONG OXIDANTS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES, EVACUATE AREA, AVOID
BREATHING VAPOR OR CONTACT WITH LIQUID. RECOVER FREE LIQUID OR STOP
LEAK, IF POSSIBLE. DIKE LARGE SPILLS AND USE ABSORBENT MATERIAL FOR
SMALL SPILLS. KEEPSPILLED MATERIAL OUT OF SEWERS, DITCHES AND
BODIES OF WATER.
*Handling and Storage *
Handling and Storage Precautions:GROUND CONTAINERS WHEN TRANSFERRING
LIQUID TO PREVENT STATIC ACCUMULATION AND DISCHARGE. DO NOT ATTEMPT
TO CLEAN "EMPTY" CONTAINERS SINCE RESIDUE IS DIFFICULT TO REMOVE.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE (LIQUID AND/OR
VAPOR) AND CAN BE DANGEROUS. DO NOT PRESSURIZE, CUT, WELD, BRAZE,
GRIND OR EXPOSE SUCH CONTAINERS TO HEAT, FLAME, SPARKS OR OTHER
SOURCES OF IGNITION; THEY MAY EXPLODE AND CAUSE INJURY OR DEATH.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:>AIR
Evaporation Rate & Reference:<ETHER
Solubility in Water:NEGLIGIBLE (< 0.1%)
Appearance and Odor:CLEAR, WATER-WHITE LIQUID; PETROLEUM ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS LIKE LIQUID CHLORINE OR CONCENTRATED OXYGEN.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE AND CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS; DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS. "EMPTY"
DRUMS SHOULD BE COMPLETELY DRAINED, PROPERLY BUNGED AND PROMPTLY
RETURNED TO SUPPLIER OR DISPOSED OF IN AN ENVIRONMENTALLY SAFE
MANNER AND IN ACCORDANCE WITH GOVERNMENTAL REGULATIONS.
* MSDS Transport Information *
Transport Information:MANUFACTURERS MSDS STATES: U.S. D.O.T. PROPER
SHIPPING NAME: PETROLEUM NAPTHA. CLASS: COMBUSTIBLE LIQUID. I.D.
PRESENT D.O.T. TRANSP ORTATION DATA FOR THIS PRODUCT IS: FLAMMABLE
* Regulatory Information *
SARA Title III Information:HAZARD CATEGORIES: IMMEDIATE (ACUTE)HEALTH,
FIRE HAZARD.
CONTAINS TRACE AMOUNTS OF BENZENE, A CHEMICAL KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER, AND TOLUENE, A CHEMICAL KNOWN TO THE
STATE OF CALIFORNIA TO CAUS E BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED
Ventilation:GENERAL VENTILATION.
Other Protective Equipment:NONE KNOWN
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
SMOKING OR EATING.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
Preparer's Name:SEROJE HARTOONIANI
* Composition/Information on Ingredients *
Ingred Name:HYDROGENATED TERPHENYLS (VAPOR PRESSURE 1 MM HG)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 PPM
ACGIH TLV:0.5 PPM
Ingred Name:DIPHENYL GUANIDINE(GUANIDINE,N,N',DIPHENYL)
Other REC Limits:NONE RECOMMENDED
Ingred Name:MANGANESE DIOXIDE (SARA III)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG MN/M3 CEILING
ACGIH TLV:5 AS MN MG/M3
ENCAPSULATED, NOT HAZARDOUS UNDER NORMAL CIRCUMSTANCES)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
ENCAPSULATED, NOT HAZARDOUS UNDER NORMAL CIRCUMSTANCES)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:SILICA DERIVATIVES (NON HAZARDOUS INGREDIENT)
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOC: 0 G/L (COMBINED PART A & B)
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:SEVERELY IRRITATING.
SKIN:IRRITATION. TOXIC BY ABSORPTION. MAY BE SENSITIZER. IRRITATION
ON MOIST SKIN. INHALATION:DIZZINESS,DROWSINESS,FATIGUE,ABSORBED
THRU LUNGS. MANGANESE PNEUMONITIS,MANGANESE POISONING. INGESTION:
TOXIC ON ORAL CONSUMPTION. APATHY,INSOMNIA,WEAKNESS IN
LEGS,MUSCULAR TWITCHING,EMOTIONAL DISTRESS
* First Aid Measures *
PERSIST, CONSULT PHYSICIAN. SKIN: WASH WITH SOAP & WATER. IF
SYMPTOMS PERSIST, CONSULT A PHYSICIAN. INHALATION: REMOVE TO FRESH
AIR. IF SYMP TOMS ARE PRESENT CONSULT A PHYSICIAN. INGESTION:
CONSULT A PHYSICIAN.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR. USE WATER TO COOL
HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:EXCESSIVE HEAT MAY CAUSE DECOMPOSITION OF
MANGANESE DIOXIDE, RESULTING IN OXIDATION AND POSSIBLE IGNITION OF
HYDROCARBON VEHICLE.
* Accidental Release Measures *
Spill Release Procedures:SCOOP INTO CONTAINERS. CLEAN-UP RESIDUE WITH A
SUITABLE SOLVENT.
*Handling and Storage *
Handling and Storage Precautions:WASH THOROUGHLY AFTER HANDLING AND
BEFORE SMOKING OR EATING. AVOID INGESTION.
* Physical/Chemical Properties *
Vapor Density:NON VOLATL
Evaporation Rate & Reference:NON VOLATILE
Solubility in Water:SLIGHT
Appearance and Odor:BLACK PASTE
Percent Volatiles by Volume:0.0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
EASILY OXIDIZABLE MATERIALS
Stability Condition to Avoid:NOT KNOWN
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN,
MANGANESE COMPOUNDS.
* Disposal Considerations *
Waste Disposal Methods:NOT A HAZARDOUS WASTE ACCORDING TO EPA
REGULATIONS. CONSULT STATE REGULATIONS PRIOR TO DISPOSAL OF
SPILLAGE.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:DO NOT BRTH VAP/MIST. IF TLV/PEL/OTHER LIMITS
ARE EXCEEDED THEN WEAR PROPERLY FITTED VAP & PARTICULATE/POSS PRESS
AIR SUPPLED RESP APPRVD BY NIOSH/MSHA FOR USE W/PAINTS DURING
Ventilation:PROVIDE SUFFICIENT VENT IN VOLUME & PATTERN TO KEEP CONTAM
Other Protective Equipment:APRON/COVERALLS/WORK CLTHES & SHOES IN CASE
OF SPILL/SPLASH. DO NOT REUSE CLOTHING OR SHOES WHILE SOLV ODOR IS
Work Hygienic Practices:AS WITH ALL CHEMICAL PRODUCTS, USE CARE IN
HANDLING. DO NOT SMOKE OR EAT WITHOUT FIRST WASHING YOUR HANDS.
Supplemental Safety and Health
EXPLO HAZ:EXPLODE WHEN EXPOS TO EXTREME HEAT. WATER FROM FOG NOZZ MAY
BE HELPFUL IN COOLING UNRUPTURED CNTNRS TO PREV PRESS BUILD-UP.
AVOID SPREADING BURNING LIQ. EFTS OF OVEREXP:OF PETROLEUM DISTILLA
TES ENTERING LUNGS IF SWALLOWED/VOM & CAUSING
INFLAMMATION/DAMAGE/EVEN DEATH. REPORTS HAVE ASSOCIATED RPTD & (ING
5)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:OTHER PROT EQUIP:RETAINED IN THEM. EYE WASHES AND SAFETY
SHOWERS MAY ALSO NEED TO BE PROVIDED.
Ingred Name:HYDROTREATED LIGHT PETROLEUM DISTILLATE
Ingred Name:HYDROCARBON RESIN
Fraction by Wt: 5%
Ingred Name:LINSEED OIL;(POLYMERIZED LINSEED OIL)
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE) (SARA III)
Fraction by Wt: 4%
Other REC Limits:NONE RECOMMENDED
Ozone Depleting Chemical:1
Ingred Name:EFTS OF OVEREXP:PROLONGED OVEREXP TO SOLV W/PERM BRAIN &
NERVOUS SYS DAM. LAB STUDIES W/RATS HAVE SHOWN THAT (ING 6)
Ingred Name:ING 5:PETROLEUM DISTILLATES CAUSE KIDNEY DAM & KIDNEY/LIVER
TUMORS. THESE EFTS WERE NOT SEEN IN SIMILAR STUDIES (ING 7)
Ingred Name:ING 6:W/GUINEA PIGS/DOGS/MONKEYS. SEVERAL STUDIES
EVALUATING PETROLEUM WORKERS HAVE NOT SHOWN SIGNIFICANT (ING 8)
Ingred Name:ING 7:INCREASE OF KIDNEY DAMAGE OR AN INCREASE IN KIDNEY OR
LIVER TUMORS.
Ingred Name:OTHER PREC:CONC & INHALING VAP OF THIS PROD MAY BE
HARMFUL/FATAL. DO NOT SAND/FLAME CUT/BRAZE/WELD DRY COATING (ING
Ingred Name:ING 9:W/OUT NIOSH/MSHA APPRVD RESP/SUFFICIENT VENT. DO NOT
Ingred Name:RESP PROT:FOLLOW RESP MANUFACTURER'S DIRECTIONS FOR PROPER
USE.
Ingred Name:VENT:USE ONLY EXPLOSION PROOF EQUIPMENT WITH FLAMMABLE
MATERIALS.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:MAY CAUSE NOSE AND THROAT
IRRITATION. MAY CAUSE NERVOUS SYS DEPRESS CHARACTERIZED BY THE
FOLLOWING PROGRESSIVE STEPS:HEADACHE, DIZZINESS, NAUSEA, STAGGERING
GAIT, LASSITUDE, LOSS OF COORDINATION , CONFUSION, UNCONSCIOUSNESS.
SKIN/EYE:RPTD/PRLNG LIQ CONTACT MAY CAUSE SKIN IRRIT W/DISCOMFORT &
DERM.(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:MAY CAUSE IRRITATION OR BURNING OF THE
EYES INCLUDING REDNESS, TEARING, AND BLURRED VISION. SKIN:SEE
INHALATION. ORGANIC SOLVENTS ARE EASILY ABSORBED. DRY SKIN,
REDNESS, OR DERMITITIS DUE TO DEFAT ACTION OF SOLVENTS ARE SIGNS
OF EXPOS. INGEST:SEE INHAL. MAY ALSO RESULT IN GI DISTRESS. THERE
IS DANGER (SUP DAT)
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN, AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP,
PREFERABLY MOUTH-TO-MOUTH, CALL MD. EYE:IMMED FLUSH WITH PLENTY OF
WATER. IF IRRI T OCCURS, CONTACT MD. INGEST:CALL MD IMMED, HAVE
NAMES OF HAZARDOUS INGRED READY, DO NOT INDUCE VOM, KEEP HEAD LOWER
THAN WAIST. ASPIRATION OF VOM MAY RESULT IN CHEM PNEUMONITIS &/OR
PULMONARY EDEMA.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL
Fire Fighting Procedures:AVOID CONFINED SPACES. FIREFIGHTERS SHOULD BE
EQUIPED W/FULL PROT EQUIP INCLUDING POS PRESS NIOSH/MSHA APPRVD
SCBA. WATER MAY BE UNSUITABLE AS AN EXTING MEDIA.
Unusual Fire/Explosion Hazard:VAP ARE HEAVIER THAN AIR & MAY ACCUMULATE
IN LOW AREAS OF POOR VENT/TRAVEL ALONG GROUND TO REMOTE IGNIT
SITES. CLSD CNTNRS CAN BUILD UP PRESS & MAY (SUPP DATA)
* Accidental Release Measures *
Spill Release Procedures:VENT AREA. REMOVE SOURCES OF IGNIT, INCLUDING
HOT METAL SURF. WEAR APPROPRIATE CLOTHING AND GEAR. PREVENT SKIN
CONTACT AND AVOID BREATHING OF VAPOR. CONFINE IMMEDIATELY AND
REMOVE WITH INERT ABSORBANT SUCH AS CLAY OR SAND.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, SPARKS AND OPEN FLAME (I.E. ALL IGNIT SOURCES). CLOSED
CONTAINERS TIGHLTY AFTER EACH USE.
Other Precautions:WASH THORO AFTER HNDLG & BEFORE EATING/SMOKING. DO
UNNECESSARY CONT. DO NOT TAKE INTERNALLY. USE W/ADEQ VENT-DO NOT
INHALE VAP. INTE NTIONAL MISUSE BY DELIBERATELY (ING 9)
* Physical/Chemical Properties *
HCC:F4
Vapor Density:>THAN AIR
Spec Gravity:1.1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:LIMITED
Appearance and Odor:LIQUID WITH PETROLEUM CHEMICAL.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS AND BASES, SELECTED AMINES.
Stability Condition to Avoid:NONE REASONABLY FORESEEABLE.
Hazardous Decomposition Products:MAY EMIT FUMES WHEN HEATED TO
DECOMPOSITION. MAY EMIT CARBON MONOXIDE, CARBON DIOXIDE,
UNIDENTIFIED ORGANIC COMPOUNDS.
* Disposal Considerations *
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. PLACE IN NON-LEAKING CONTAINERS. DISPOSE OF ABSORBED
MATERIAL IN ACCORDANCE WITH ALL FEDERAL, STATE, AND LOCAL
REQUIREMENTS. DO NOT INCINERA TE IN CLOSED CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF DUSTY CONDITIONS PREVAIL, USE OF AN APPROVED
NIOSH DUST MASK IS RECOMMENDED.
Ventilation:NOT PROVIDED.
Other Protective Equipment:LONG SLEEVES
Work Hygienic Practices:AVOID PROLONGED BREATHING OF THE DUST OR
CONTACT WITH THE SKIN.
Supplemental Safety and Health
NONE
* Product Identification *
Preparer's Name:NOT PROVIDED.
CAGE:1L2Z7
CAGE:1L2Z7
* Composition/Information on Ingredients *
Ingred Name:SODIUM OXIDE
Fraction by Wt: NOT PROVID
Other REC Limits: RECOMMENDED
Ingred Name:CALCIUM OXIDE
Fraction by Wt: NOT PROVID
Other REC Limits: RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:POTASSIUM OXIDE
Fraction by Wt: NOT PROVID
Other REC Limits: RECOMMENDED
Ingred Name:SILICA (SYNTHETIC)
Fraction by Wt: NOT PROVID
Other REC Limits: RECOMMENDED
OSHA PEL:6 MG/M3
Fraction by Wt: NOT PROVID
Other REC Limits: RECOMMENDED
Code:F
OSHA STEL:5 MG/M3
Ingred Name:CLAY
Fraction by Wt: NOT PROVID
Other REC Limits: RECOMMENDED
Ingred Name:QUARTZ
Fraction by Wt: NOT PROVID
Other REC Limits: RECOMMENDED
OSHA STEL:0.1 MG/M3 RESP.
ACGIH STEL:0.1 MG/M3 RESP.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MOLECULAR SIEVES ARE NON-FIBROUS,
SYNTHETIC ALUMINOSILICATES (ZEOLITES) AND THEY DO NOT CAUSE
SIGNIFICANT HEALTH PROBLEMS. WHEN ACTIVATED, MOLECULAR SEIVES ACT
ASA DESICCANT AND CAN CAUSE A DRYING IRRITATION OF MUCOUS
MEMBRANES AND SKIN IN CASE OF SEVERE EXPOSURE. QUARTZ CAN CAUSE
CANCER, SILICOSIS OR OTHER FIBROTIC LUNG DISEASE WITH PROLONGED
EXPOSURE.
Explanation of Carcinogenicity:CONTAINS QUARTZ.
Effects of Overexposure:IRRITATION OF MUCOUS MEMBRANES OF NOSE, THROAT.
IRRITATION OF SKIN.
Medical Cond Aggravated by Exposure:NO MEDICAL CONDITIONS ABNORMALLY
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
First Aid:EYES: IMMEDIATELY WASH FROM EYES WITH LARGE AMOUNT OF WATER,
OCCASIONALLY LIFTING UPPER AND LOWER EYELIDS. IF IRRITATION OCCURS
AND PERSISTS, SEEK MEDICAL ATTENTION . SKIN: WASH WITH SOAP AND
WATER. INGESTION: MATERIAL WILL PASS THROUGH BODY NORMALLY.
INHALATION: REMOVE TO FRESH AIR.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NOT PROVIDED.
Fire Fighting Procedures:NOT PROVIDED.
Unusual Fire/Explosion Hazard:NOT PROVIDED.
* Accidental Release Measures *
Spill Release Procedures:VACUUM OR SWEEP UP OR FLUSH TO SEWER TREATED
FOR SUSPENDED SOLIDS REMOVAL.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY SEALED TO
PROTECT PRODUCT QUALITY.
Other Precautions:WHEN POURING INTO CONTAINER OF FLAMMABLE LIQUID
GROUND BOTH CONTAINERS ELECTRICALLY TO PREVENT STATIC ELECTRIC
SPARK. WILL RELEASE HEAT WHEN ADSORBING WATER.LARGE QUANTITIES OF
SIEVE QUICKLY ADSORBS EQUILIBRIUM AMOUNT OF WATER, SIEVES BECOME
HOT ENOUGH TO CAUSE THERMAL BURNS ON THE SKIN. AVOID CONT ACT.
* Physical/Chemical Properties *
HCC:N1
Boiling Pt:B.P. Text:NP
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:NP
Vapor Density:NP
Spec Gravity:2.1
Viscosity:NOT APPLICABLE.
Evaporation Rate & Reference:NOT APPLICABLE.
Solubility in Water:INSOLUBLE.
Appearance and Odor:WHITE, GRAY, OR TAN, BEADS, ODORLESS.
Percent Volatiles by Volume:NP
Corrosion Rate:NP
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REACTS WITH HF & STRONG ACIDS OR ALKALI.
Stability Condition to Avoid: SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: SPECIFIED BY MANUFACTURER.
* Toxicological Information*
* Disposal Considerations *
Waste Disposal Methods:LANDFILL IN ACCORDANCE QITH LOCAL,STATE AND
FEDERAL REGULATIONS. COVER TO AVOID BLOWING OF DUST.
* Regulatory Information *
Federal Regulatory Information:TSCA. EPA HAS DEFINED ZEOLITES AS
COMPLEX CHEMICAL PRODUCTS CONSISTING OF SILICA (SIO2) AND ALUMINA
(AL2O3), IN VARIOUS PROPORTIONS PLUS METALLIC OXIDES AND CERTAIN
CATIONS.
State Regulatory Information:
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:NONE REQUIRED
Work Hygienic Practices:NORMAL CARE IN HANDLING.
Supplemental Safety and Health
* Product Identification *
Product ID:HYDROSEP
Preparer's Name:GABE MAZIE
* Composition/Information on Ingredients *
Ingred Name:CHLORHEXIDINE GLUCONATE
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYE: IRRITATION WHEN EXPOSED TO
CONCENTRATED DOSAGES ONLY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: IRRITATION WHEN EXPOSED TO
CONCENTRATED DOSAGES ONLY.
Medical Cond Aggravated by Exposure:DERMATITIS.
* First Aid Measures *
First Aid:FLUSH W/1-2 LITERS OF WATER. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Flash Point:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:FLUSH W/WATER.
*Handling and Storage *
Handling and Storage Precautions:DON'T SPILL ON SKIN/INTO EYES/EARS.
FLUSH W/1-2 LITERS OF WATER.
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:N1
Boiling Pt:B.P. Text:AS WATER
Melt/Freeze Pt:M.P/F.P Text:AS WATER
Vapor Pres:AS WATER
Vapor Density:AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:WATER LIKE.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
* Disposal Considerations *
Waste Disposal Methods:FLUSH W/WATER IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Other Protective Equipment:LAB COAT
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:STEPHEN M. BACON
* Composition/Information on Ingredients *
Ingred Name:BERYLLIUM SULFATE TETRAHYDRATE
Fraction by Wt: 1.2%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: DERMATITIS, REDNESS, IRRITATION,
& ULCERS. INHALATION: IRRITATION OF NASAL PASSAGES & RESPIRATORY
TRACT & PNEUMONITIS. EYES: IRRITATION & CONJUNCTIVAL INFLAMMATION.
INGESTION: DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: DERMATITIS, IRRITATION, REDNESS, &
ULCERS. INHALATION: IRRITATION OF NASAL PASSAGES, RESPIRATORY TRACT
& PNEUMONITIS. EYES: IRRITATION & CONJUNCTIVAL INFLAMMATION.
INGESTION: DEATH.
* First Aid Measures *
First Aid:SKIN: FLUSH W/WATER. WASH W/SOAP & WATER. EYES: FLUSH
INTERNALLY, DRINK WATER OR MILK & INDUCE VOMITING. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. IF BREATHING STOPS, GIVE ARTIFICIAL
RESPIRATION. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER, CO2, FOAM, DRY CHEMICAL
Unusual Fire/Explosion Hazard:TOXIC BERYLLIUM OXIDE & SULFURIC ACID
FUMES MAY FORM IN FIRE.
* Accidental Release Measures *
Spill Release Procedures:ABSORB W/VERMICULITE, SAND OR OTHER INERT
MATERIAL & CONTAINERIZE FOR LATER DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT W/SKIN, EYES/CLOTHING.
PROTECT FROM EVAPORATION & DECOMPOSITION.
* Physical/Chemical Properties *
Vapor Density:0.6
Spec Gravity:1
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS, WATER LIKE LIQUID; ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:TOXIC OXIDES OF BERYLLIUM & SULFUR
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF BY INCINERATION OR OTHER METHOD
APPROVED OF BY LOCAL, STATE, OR FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE.
Ventilation:MECHANICAL (GENERAL).
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . NORMAL LABORATORY APPAREL.
Work Hygienic Practices:WASH W/SOAP & WATER AFTER HANDLING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:PACK BUFFER PH 6.8.
* Product Identification *
CAGE:0B0Y1
CAGE:0B0Y1
* Composition/Information on Ingredients *
Ingred Name:PHOSPHORIC ACID, MONOPOTASSIUM SALT; (POTASSIUM PHOSPHATE
(MONO))
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM PHOSPHATE, DIBASIC (CERCLA). MFR'S CAS
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: TRACE
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS NOT EXPECTED TO PRESENT A
HEALTH HAZARD WHEN EMPLOYING GOOD LABORATORY PRACTICES. EFFECTS OF
OVEREXPOSURE: IRRITATION OF EYES AND SKIN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . INGEST:INDUCE VOMITING OF CONSCIOUS PATIENT BY GIVING TWO
GLASSES OF WATER & PRESSING FINGER DOWN THROAT. CONTACT MD
IMMEDIATE LY. SKIN:REMOVE CONTAMINATED CLOTHING &WASH SKIN W/WATER.
IF IRRITATION PERSISTS, CONTACT MD. EYES:FLUSH W/WATER FOR AT LEAST
* Fire Fighting Measures *
Flash Point:NON FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILL W/ABSORBENT MATERIAL OR MOP UP
W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NORMAL LABORATORY CARE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID; ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL SHOULD BE CARRIED OUT I/A/W FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED. IF NECESSARY, USE NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:MECHANICAL (GENERAL): MAINTAIN ADEQUATE VENTILATION.
Other Protective Equipment:NOT REQUIRED.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Preparer's Name:RICK LOWE
* Composition/Information on Ingredients *
Ingred Name:ALKANES, C-3 TO C-4 (PROPELLANT)
Fraction by Wt: 1.5%
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL IF SWALLOWED. MAY CAUSE
EYE OR SKIN IRRITATION. CAUSES GASTROINTESTINAL IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:UNKNOWN TO THE MANUFACTURER.
* First Aid Measures *
First Aid:SKIN: WASH OFF WITH SOAP & WATER. EYES: FLUSH W/WATER FOR A
DRINK LARGE AMOUNTS OF WATER OR MILK. CALL MD. INHAL: REMOVE TO
FRESH AIR. SU PPORT BREATHING (GIVE O*2/ARTF RESP) .
* Fire Fighting Measures *
Flash Point Method:TOC
Extinguishing Media:WATER FOG.
Fire Fighting Procedures:TREAT AS CYLINDER OF COMPRESSED GAS. KEEP
CONTAINERS COOL. USE NIOSH/ MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
CONTAINERS MAY VENT, RUPTURE OR BURST.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF HEAT, FLAMES OR SPARKS.
PROVIDE ADEQUATE VENTILATION. MOP UP SPILLS, THEN RINSE WITH WATER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:CONTENTS UNDER PRESSURE. STORE IN A
DRY, COOL AREA. KEEP OUT OF REACH OF CHILDREN. DO NOT STORE WHERE
Other Precautions:READ ENTIRE LABEL BEFORE USING.
* Physical/Chemical Properties *
Vapor Density:<AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, LIGHT GREEN LIQUID PLEASANTLY SCENTED.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:AVOID HEATING TO ABNORMAL TEMPERATURES.
Hazardous Decomposition Products:CO*X FORMED UPON COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:DO NOT PUNCTURE OR INCINERATE CONTAINERS.
REPLACE CAP & DISCARD CONTAINER IN TRASH. DISPOSAL MUST BE I/A/W
FEDERAL, STATE, AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A NIOSH APPROVED CHEMICAL CARTRIDGE
RESPIRATOR TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY DURING
SPRAY APPLICATION.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST IN VOLUME & PATTERN TO KEEP
TLV BELOW ACCEPTABLE LIMITS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:1,2-PROPANEDIOL (PROPYLENE GLYCOL)
Fraction by Wt: 5%
Ingred Name:PROPANOIC ACID, 2-METHYL, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL, TEXANOL(ESTER ALCOHOL)
Fraction by Wt: 5%
Ingred Name:DIETHYLENE GLYCOL METHYL ETHER, 2-(2-METHOXYETHOXY) ETHANOL
METHYL CARBITOL
Fraction by Wt: 0.3%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF NOSE, THROAT
& LUNGS. SKIN/EYES: PRIMARY IRRITANT. INGESTION: GI IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, NAUSEA, VOMITING,
DIARRHEA.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH IMMEDIATELY
W/SOAP & WATER. INGESTION: DILUTE STOMACH CONTENTS W/TWO GLASSES OF
WATER & INDU CE VOMITING BY EITHER GIVING IPECAC SYRUP/BY PLACING
TWO FINGERS AT BACK OF THROAT. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Fire Fighting Procedures:WATER MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT BUILD-UP OF STEAM. IF WATER IS USED, FOG NOZZLES ARE
PREFERRED.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT DUE TO BUILD-UP OF STEAM.
* Accidental Release Measures *
Spill Release Procedures:SOAK UP LIQUID W/ABSORBENT & SHOVEL INTO WASTE
CONTAINER. WASH AREA W/WATER & FLUSH TO SEWER SERVICED BY WASTE
WATER TREATMENT FACILITY.
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM FREEZING.
* Physical/Chemical Properties *
Vapor Density:>1
pH:8-9.2
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXTREME HEAT, OPEN FLAME, FREEZING.
Hazardous Decomposition Products:CO & CO2.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:VAPOR RESPIRATOR. BE SURE TO USE NIOSH APPROVED
RESPIRATOR. WEAR APPROPRIATE RESPIRATOR WHEN VENTILATION IS
INADEQUATE.
Ventilation:PROVIDE EXHST VENT OR OTHER ENGINEERING CTLS TO KEEP
AIRBORNE CONCS OF VAPS BELOW THEIR RESPECTIVE THRESHOLD LIM VALUE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER ;
ENSURE PROXIMAL TO WORK-STATION LOCATION. LAB COAT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:E. BRULL
* Composition/Information on Ingredients *
Ingred Name:SUPDAT: CREVICES, CREASES & GROIN. COLD WATER MAY BE USED.
COVER IRRITATED SKIN W/EMOLLIENT. IF IRRIT PERSISTS, (ING 3)
Ingred Name:ING 2: SEEK MED ATTN. WASH CONTAM CLTHG BEFORE REUSING.
SERIOUS SKIN CNTCT: WASH W/DISINFECTANT SOAP & COVER (ING 4)
Ingred Name:ING 3: CONTAM SKIN W/ANTI-BACTERIAL CREAM. SEEK IMMED MED
ATTN. INHAL:REST IN WELL VENTD AREA. SEEK IMMED MED (ING 5)
Ingred Name:ING 4: ATTN. SERIOUS INHAL:EVACUATE TO SAFE AREA AS SOON AS
POSS. LOOSEN TIGHT CLTHG. IF BRTHG DFCLT, ADMIN O*2. (ING 6)
Ingred Name:ING 5: IF NOT BRTHG, PERFORM MOUTH-TO-MOUTH RESUSCITATION.
WARNING:IT MAY BE DANGEROUS TO PERSON PROVIDING AID TO(ING 7)
Ingred Name:ING 6: GIVE MOUTH-TO-MOUTH RESUSCITATION WHEN INHALED MATL
IS TOX, INFECTIOUS/CORR. SEEK IMMED MED ATTN. INGEST: (ING 8)
Ingred Name:ING 7:REMOVE DENTURES IF ANY. WATCH FOR OBSTRUCTION IN
MOUTH; REMOVE IF POSS BUT DO NOT FORCE FINGERS/HARD OBJECT(ING 9)
Ingred Name:ING 8: BETWEEN TEETH. HAVE CONSCIOUS PERSON DRINK SEVERAL
Ingred Name:ING 9: IN THROAT. SEEK IMMED MED ATTN. SERIOUS
INGEST:EXAMINE LIPS & MOUTH TO ASCERTAIN IF TISS DAMAGED, POSS (ING
Ingred Name:SPILL PROC: TOUCH SPILLED MATL. PVNT ENRY INTO SEWERS,
PROD.
Ingred Name:HNDLG/STOR PRECS: VENTD PLACE. GROUND EQUIP CNTNG MATL.
Ingred Name:OTHER PRECS: MED ADVICE IMMED & SHOW CONTAINER OR LABEL.
AVOID CONTACT W/SKIN & EYES.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: VERY DANGEROUS IN CASE OF
INGESTION. SLIGHTLY DANGEROUS TO DANGEROUS IN CASE OF SKIN CONTACT
(IRRITANT), OF EYE CONTACT (IRRITANT), OF INHALATION. VERY SLIGHTLY
TO SLIGHTLY DANGEROUS IN CASE OF SKIN CONTACT (PERMEATOR). SEVERE
OVEREXP CAN RESULT IN DEATH. CAN BE FATAL IF INHALED OR INGESTED.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: THIS PRODUCT MAY IRRITATE EYES & SKIN
UPON CONTACT. CHRONIC: THIS SUBSTANCE IS TOXIC TO LUNGS, MUC MEMBS.
TOXICITY OF PROD TO REPRO SYS: NOT AVAIL. RPTD/PRLNGD EXPOS TO
SUBSTANCE CAN PRDCE T ARGET ORGANS DAMAGE. RPTD EXPOS TO HIGHLY TOX
MATL MAY PRDCE GEN DETERIORATION OF HLTH BY ACCUM IN ONE/MANY
ORGANS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYES: CHECK FOR & REMOVE CNTCT LENSES. IMMED FLUSH W/RUNNING
DO NOT USE EYE OINTMENT. SEEK MED ATTN. SKIN: IF CHEM GOT ONTO
CLOTHED PORTION OF BODY, REMOVE CONTAMD CLOTHESAS QUICKLY AS POSS,
PROTECTING YOUR OWN HANDS & BODY. PLACE VICTIM UNDER DELUGE SHOWER.
IF CHEM TOUCHES VICTIM'S EXPOS SKIN, SUCH AS HANDS: GENTLY &
(SUPDAT)
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:2.2%
Extinguishing Media:SMALL FIRE: USE DRY CHEMS, CO*2, ALCOHOL FOAM OR
WATER SPRAY. LARGE FIRE: USE ALCOHOL FOAM, WATER SPRAY OR FOG.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP . FLAM
LIQ, SOL/DISPERSED IN WATER. COOL CONTAINING VESSELS W/WATER JET IN
ORDER TO PVNT PRESS BUILD-UP, (SUPDAT)
Unusual Fire/Explosion Hazard:PRODS OF COMBUST ARE CARBON OXIDES (CO,
CO*2). SLIGHTLY FLAM IN PRESENCE OF OPEN FLAMES & SPKS. VERY
SLIGHTLY TO SLIGHTLY FLAM & EXPLO IN PRESENCE OF (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:LG SPILL:DILUTE W/WATER & MOP UP OR ABSORB
W/INERT DRY MATL & PLACE IN APPRVD WASTE DISP CNTNR. LG SPILL: FLAM
LIQ. KEEP AWAY FROM HEAT & SOURCES OF IGNIT. STOP LEAK IF W/OUT
RISK. ABSORB W/DRY EARTH, SAND/OTHER NON-COMBUST MATL. DO NOT (ING
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE FLAM MATLS IN SEPARATE SFTY STOR
CABINET/ROOM. KEEP AWAY FROM HEAT & SOURCES OF IGNIT. KEEP CNTNR
Other Precautions:KEEP LOCKED UP. KEEP AWAY FROM HEAT & SOURCES OF
IGNIT. GROUND ALL EQUIP CONTAINING MATL. DO NOT INGEST. DO NOT
BREATHE GAS, FUMES, VAP/SPRAY. IN CASE OF INSUFFICIENT VENT, WEAR
FIRE FIGHT PROC: AUTOIGNIT/EXPLO. EXPLO HAZ: OXIDIZING MATLS, OF
ACIDS, OF ALKALIS. MATL TO AVOID: IN PRESENCE OF GLASS. FIRST AID P
ROC: THOROUGHLY WASH CONTAM SKIN W/RUNNING WATER & NON-ABRASIVE
SOAP. BE PARTICULARLY CAREFUL TO CLEAN FOLDS, (ING 2)
* Physical/Chemical Properties *
Solubility in Water:SUPDAT
Appearance and Odor:LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NO SPECIFIC INFO AVAIL IN DATABASE REGARDING REACTIVITY OF MATL IN
PRESENCE OF VARIOUS OTHER MATLS. NON-CORR (SUPDAT)
Stability Condition to Avoid:NO ADDITIONAL REMARK.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:RECYCLE TO PROCESS, IF POSSIBLE. CONSULT YOUR
FEDERAL, STATE, LOCAL OR REGIONAL AUTHORITIES.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . WHEN USED IN CONFINED AREAS, WEAR NIOSH/MSHA
APPROVED RESPIRATOR.
Ventilation:PROVIDE GENERAL DILUTION OR LOCAL EXHAUST.PREVENT BUILD UP,
REMOVE HEAVY SOLVENTS FROM LOWER LEVEL OF WORK AREA.
Other Protective Equipment:SOLVENT IMPERMEABLE CLOTHING AND BOOTS TO
PREVENT SKIN CONTACT.
Work Hygienic Practices:REMOVE AND WASH SOILED CLOTHING BEFORE
REUSE.WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
& PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. PROLONGED OR REPEATED BREATHING OF
SPRAY MIST &/OR SANDING DUST OVER A PERIOD OF YEARS MAY CAUSE DUST
DISEASE OF THE LUNGS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:N-BUTYL ALCOHOL (SARA III)
Other REC Limits:N/E(MFR)
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Other REC Limits:N/E(MFR)
Ingred Name:METHYL N-AMYL KETONE
Other REC Limits:N/K
Ingred Name:ISOBUTYL ISOBUTYRATE
Other REC Limits:N/E (MFR)
OSHA PEL:N/E (MFR)
ACGIH TLV:N/E (MFR)
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE, WHEN USED IN ACCORDANCE WITH
SAFE HANDLING & USE INFORMATION.
Explanation of Carcinogenicity:N/A
Effects of Overexposure:BREATHING:IRRITATION OF THE RESPIRATORY
TRACT;HEADACHE,NAUSEA,DIZZINESS,WEAKNESS,&FATIGUE. EXTREME EXPOSURE
CAN RESULT IN UNCONSCIOUSNESS & EVEN RESPIRATORY ARREST.SKIN OR EYE
CONTACT:PRIMARY IRRITATI ON. SWALLOWING:CAN CAUSE STOMACH &/OR
INTESTINAL IRRITATION,NAUSEA & DIARRHEA. CHRONIC: REPORTS HAVE (SEE
SUP DATA)
Medical Cond Aggravated by Exposure:SEE HEALTH HAZARDS
* First Aid Measures *
First Aid:BREATHED:DIFFICULTY IN BREATHING,LEAVE AREA TO OBTAIN FRESH
AIR.BREATHING CEASES,RESTORE USING APPROVED CPR TECHNIQUES & SUMMON
MEDICAL HELP.EYES:FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF H*2O FOR
H*2O,REMOVE SOILED CLOTHING,GET MED HELP,IF IRRITATION
PERSISTS.INGEST:CONSULT A PHYSICIAN IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:SCC
Upper Limits:NE
Extinguishing Media:CO*2,DRY CHEMICAL,FOAM FOR CLASS B FIRE VAPOR MAY
CAUSE FLASH FIRE OR IGNITE EXPLOSIVELY.VAPORS MAY SPREAD ALONG
FLOOR
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT,INCLUDING SELF
CONTAINED BREATHING APPARATUS,WATER FOG NOZZLES PREFERED. USE TO
COOL CONTAINERS & PREVENT AUTO IGNITION.
Unusual Fire/Explosion Hazard:DUE TO PRESSURE BUILD UP CLOSED CONTAINER
EXPOSED TO EXTREME HEAT MAY EXPLODE,NEVER USE WELDING OR CUTTING
TORCH NEAR CONTAINERS(EVEN EMPTY)RESIDUE MAY IGNITE.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. PREVENT
BREATHING OF VAPORS, VENTILATE AREA, CONTAIN SPILLED MATERIAL &
REMOVE WITH INERT ABSORBENT & NON-SPARKING TOOLS. STORE IN CLOSED
CONTAINER UNTIL PROPERLY DISPO SED OF.
Neutralizing Agent:N/K
*Handling and Storage *
OR OPEN FLAME.
Other Precautions:N/K
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:NONE (MFR)
Vapor Pres:NONE (MFR)
Spec Gravity:NONE (MFR)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NONE (MFR)
Appearance and Odor:N/E
Corrosion Rate:
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
SEE CONDITIONS TO AVOID STABILITY
Stability Condition to Avoid:AVOID CONTACT WITH STRONG OXIDIZING
AGENTS.
Hazardous Decomposition Products:MAY CAUSE HAZARDOUS FUMES WHEN HEATED
TO DECOMPOSITION MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE &
FEDERAL REGULATIONS.INCINERATE ONLY IN APPROVED FACILITY, DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR DUST IF
NEEDED.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:AS REQUIRED TO PREVENT PROLONGED CONTACT.
Supplemental Safety and Health
* Product Identification *
Product ID:STANDARD SOLDER SEAL, PART NO. C5
* Composition/Information on Ingredients *
Ingred Name:VEGETABLE FIBER
Ingred Name:SODIUM CARBONATE (USED AS FILLER)
Ingred Name:SOAP (USED AS FILLER)
Ingred Name:ALUMINUM (SARA III)
Ingred Name:SULFUR (USED AS FILLER)
* Hazards Identification *
Effects of Overexposure:MAY BE IRRITATING TO NASAL MEMBRANES AND
EYES;AVOID INHALATION
* First Aid Measures *
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER CO*2,CHEMICAL POWDER
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;SWEEP AND
COLLECT FOR PROPER DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY PLACE.
Other Precautions:DO NOT INHALE DUST IF CREATED
* Physical/Chemical Properties *
HCC:N1
Vapor Density:<0.5
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COAASE POWDER WITH SILVERY GRAY COLOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT APPLICABLE.
Ventilation:NOT APPLICABLE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
APPEAR/ODOR:COMPOUND. IT COMES IN VARIOUS SIZES & IN SEVERAL FORMS;
E.G., PIPE INSULATION, SHEET INSULATION & INSULATING TAPE.
* Product Identification *
Product ID:AP ARMAFLEX TUBE
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT IS CLASSIFIED AS AN
DESIGN DURING MANUFACTURE, HAS END U SE FUNCTIONS DEPENDENT UPON
THEIR SHAPE& DESIGN, & DOES NOT RELEASE ANY HAZ CHEMICAL UNDER
NORMAL CNDTNS OF USE.
Explanation of Carcinogenicity:NOT RELEVANT
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:IMMEDIATELY FLUSH
MD. SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD .
* Fire Fighting Measures *
Extinguishing Media:WATER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Appearance and Odor:BLACK. THIS PROD IS AN EXPANDED, CLSD-CELL,
SULFUR-CURED RUBBER TYPE (SUPDAT)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:AMMONIUM THIOSULFATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM BISULFITE (CERCLA)
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ALUMINUM SULFATE
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
Ingred Name:SODIUM BISULFITE (SASA III) (CERCLA)
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY CAUSE TRANSIENT EYE IRRITATION. LOW
SKIN CONTACT HAZARD FOR RECOMMENDED HANDLING. EXPECTED TO BE A LOW
INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMEEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSTION PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING. KEEP FROM CONTACT WITH OXIDIZING
MATERIALS. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:KEEP AWAY FROM INCOMPATIBLE MATERIALS.
* Physical/Chemical Properties *
HCC:C3
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Density:0.6
pH:4.1
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASES, SODIUM HYPOCHLORITE (BLEACH), STRONG OXIDIZING AGENTS, STRONG
ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AMMONIA, NITROGEN OXIDES, SULFUR
DIOXIDE, CHLORAMINE.
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A NIOSH/MSHA CHEMICAL CARTRIDGE RESPIRATOR
SHOULD BE WORN IF PEL OR TLV IS EXCEEDED.
Ventilation:LOCAL EXHAUST: YES. MECHANICAL (GENERAL): YES.
Other Protective Equipment:LAB COAT, EYE WASH, AND SAFETY SHOWER.
Supplemental Safety and Health
* Product Identification *
Product ID:POTASSIUM HYDROXIDE, 2%
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM HYDROXIDE
= Wt:2.
ACGIH STEL:C2 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:TARGET ORGANS: ABDOMINAL PAIN.
EYES-MAY CAUSE IRRITATION. SKIN-MAY CAUSE IRRITATION. INGESTION-MAY
CAUSE GASTROINTESTINAL DISCOMFORT. INHALATION-MAY CAUSE IRRITATION
TO RESPIRATORY TRACT.
* First Aid Measures *
OCCASIONALLY. GET MEDICAL AID IF IRRITATION PERSISTS.
CLOTHES. LAUNDER C ONTAMINATED CLOTHING BEFORE REUSE. GET MEDICAL
AID IF IRRITATION PERSISTS. INGESTION-IF SWALLOWED, IF CONSCIOUS,
GIVE PLENTY OF WATER. IMMEDIATELY CALL A PHYSICIAN OR POISON
CONTROL CENTER. NEVER GIVEANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. INHALATION-REMOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING IS
DIFFICULT; GIVE ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED.
KEEP PERSON WARM, QUIET, & GET MEDICAL AID.
* Fire Fighting Measures *
Extinguishing Media:USE DRY CHEMICAL, CARBON DIOXIDE OR APPROPIATE
FOAM.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR SELF-CONTAINED
BREATHING APPARATUS AND FULL FIRE FIGHTER'S PROTECTIVE GEAR.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE SPILL AREA. ELIMINATE ALL SOURCES OF
IGNITION. REMOVE ALL NON0-ESSENTIAL PERSONNEL FROM AREA. CLEAN-UP
PERSONNEL SHOULD WEAR PROPER PERSONAL PROTECTIVE GEAR. ABSORB
MATERIAL WITH SUITABLE AB SORBANT AND CONTAINERIZE FOR DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:KEEP IN A TIGHTLY CLOSED CONTAINER,
STORED IN A COOL, DRY VENTILATED AREA. PROTECT AGAINST PHYSICAL
DAMAGE AND FREEZING. SEPARATE FROM INCOMPATIBILITIES.
* Physical/Chemical Properties *
HCC:B1
Solubility in Water:MISCIBLE WITH WATER
Appearance and Odor:ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MATERIAL DOES NOT POLYMERIZE, ACIDS.
Hazardous Decomposition Products:POTASSIUM OXIDE AT VERY HIGH
TEMPERATURES.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Toxicological Information*
REFERENCE CITED.
* Ecological Information *
Ecological:NONE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS. ALWAYS CONTACT A PERMITTED WASTE
DISPOSER (TSD) TO ASSURE COMPLIANCE.
* MSDS Transport Information *
CORROSIVE.
* Regulatory Information *
REPORTING: ACUTE.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
NECESSARY.
Ventilation:USE PROCESS ENCLOSURE, LOC EXHST VENT OR OTHER ENGINEERING
CTLS TO CTL AIRBORNE LEVELS BELOW RECOMMENDED EXPOS LIMITS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO MINIMIZE CONTACT WITH SKIN.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATL TO AVOID: ACROLEIN, ACRYLONITRILE, ALCOHOLS + HYDROGEN PEROXIDE,
ALLYL ALCOHOL, ALLYL CHLORIDE, 2-AMINOETHANOL, AMMONIUM HYDROXIDE,
AMMONIUM TRIPERCHROMATE, ANILINE, BROMATES + METALS, BROMINE PE
NTAFLUORIDE, N-BUTYRALDEHYDE, CARBIDES,CESIUM ACETYLENE CARBIDE,
CHLORATES, CHLORINE TRIFLUORIDE, (ING 3)
* Product Identification *
* Composition/Information on Ingredients *
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 3 STEL
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT: CHLOROSULFONIC ACID, CUPROUS NITRIDE,
DIISOBUTYLENE, EPICHLOROHYDRIN, ETHYLENE CYANOHYDRIN, ETHYLENE (ING
4)
Ingred Name:ING 3: DIAMINE, ETHYLENE GLYCOL, ETHYLENIMINE, FULMINATES,
OTHER ACIDS, IODINE HEPTAFLUORIDE, METALS, ISOPRENE, (ING 5)
Ingred Name:ING 4: LITHIUM SILICIDE, MERCURIC NITRIDE, MESITYL OXIDE.
Ingred Name:FIRST AID PROC: ANYTHING BY MOUTH TO AN UNCON PERSON. GET
MED AID IMMED. INHAL: GET MED AID IMMED. REMOVE FROM (ING 7)
Ingred Name:ING 6: EXPOSURE TO FRESH AIR IMMED. IF NOT BREATHING, GIVE
ARTF RESP. IF BREATHING IS DIFFICULT, GIVE OXYGEN. (ING 8)
Ingred Name:ING 7: NOTES TO MD: TREAT SYMPTOMATICALLY & SUPPORTIVELY.
ANTIDOTE: NONE REPORTED.
Ingred Name:HNDLG/STOR PRECS: FROM INCOMPATIBLE SUBSTANCES. DO NOT
STORE NEAR ALKALINE SUBSTANCES.
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE: CAUSES SEVERE EYE BURNS. MAY
CAUSE IRREVERSIBLE EYE INJURY. SKIN: CAUSES SKIN BURNS. INGESTION:
MAY CAUSE SEVERE AND PERMANENT DAMAGE TO THE DIGESTIVE TRACT.
CAUSES GASTROINTESTINAL TRACT BURNS. INHALATION: MAY CAUSE SEVERE
IRRITATIONOF THE RESPIRATORY TRACT WITH SORE THROAT, COUGHING,
SHORTNESS (EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ: OF BREATH AND DELAYED LUNG EDEMA.
CAUSES CHEMICAL BURNS TO THE RESPIRATORY TRACT. CHRONIC: NO
INFORMATION FOUND. TARGET ORGAN: NONE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
OCCASNLY LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN: GET
MIN WHILE R EMOVING CONTAM CLTHG & SHOES. SPEEDY ACTION IS
CRITICAL! DESTROY CONTAM SHOES. INGEST: DO NOT INDUCE VOMITING. IF
VICTIM IS CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK OR WATER.
NEVER GIVE (ING 6)
* Fire Fighting Measures *
Extinguishing Media:USE WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS.
USE DRY CHEMICAL TO FIGHT FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:CLEAN UP SPILLS IMMEDIATELY, OBSERVING
PRECAUTIONS IN THE PROTECTIVE EQUIPMENT SECTION. COVER WITH SAND,
DRY LIME OR SODA ASH AND PLACE IN A CLOSED CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT STORE NEAR COMBUSTIBLE MATLS.
KEEP CNTNRS CLOSED WHEN NOT IN USE. STORE IN A DRY AREA. STORE IN A
COOL, DRY, WELL-VENTILATED AREA AWAY (ING 9)
Other Precautions:WASH THOROUGHLY AFTER HANDLING. REMOVE CONTAMINATED
CLOTHING AND WASH BEFORE REUSE. DO NOT GET IN EYES, ON SKIN OR ON
CLOTHING. KEEP CONTAINER TIGHTLY CLOSED. USE ONLY IN A CHEMICAL
FUME HOOD.
* Physical/Chemical Properties *
Spec Gravity:>1.0
pH:<1.0
Appearance and Odor:COLORLESS LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACETIC ANHYDRIDE, ACETONE CYANHYDRIN, ACETONE + NITRIC ACID, ACETONE +
POTASSIUM DICHROMATE, ACETONITRILE, (SUPDAT)
Stability Condition to Avoid:INCOMPATIBLE MATERIALS, METALS, EXCESS
HEAT, COMBUSTIBLE MATERIALS, ORGANIC MATERIALS, OXIDIZERS, AMINES,
BASES.
Hazardous Decomposition Products:OXIDES OF SULFUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE AND LOCAL REGULATIONS. NOT LISTED AS A MATERIAL BANNED FROM
LAND DISPOSAL ACCORDING TO RCRA.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ADEQUATE VENTILATION IS REQUIRED. USE NIOSH/MSHA
APPROVED RESPIRATOR DEVICE. SEE YOUR SAFETY EQUIPMENT SUPPLIER FOR
EVALUATION & RECOMMENDATION. IN CONFINED AREAS, USE NIOSH/MSHA
APPROVED AIRLINE RESP IRATOR OR HOOD.
Ventilation:PROVIDE SUFFICIENT VENT TO KEEP VAP CONC BELOW GIVEN
Other Protective Equipment:EYE BATH/SHOWER SHOULD BE AVAIL. USE CHEM
RESISTANT APRON/BOOTS/OTHER CLTHG IF NEEDED TO AVOID RPTD/FREQUENT
SKIN CONT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM.
Supplemental Safety and Health
EXPLO HAZ:SURF REQS SPEC PRECS. DURING EMER CNDTNS OVEREXPOS TO DECOMP
PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN
MED ATTN. EFTS OF OVEREXP:RESP SYS. DRY DUST MAY CAUSE MECH EYE
IRRIT. ACCUM OF SANDING DUST/DRY SPRAYON SKIN MAY LEAD TO
* Product Identification *
Preparer's Name:CHARLES L. GRUBBS
* Composition/Information on Ingredients *
Ingred Name:OTHER PREC:CUT EMPTY DRUM. CONTAINS CHROMATE PIGMENTS. IF
MANUFACTURER'S SAFETY PRECAUTIONS HAVE BEEN READ & UNDERSTOOD.
Ingred Name:VENT:HEATING. REMOVE DECOMPOSITION PRODUCTS FORMED DURING
WELDING OR FLAME CUTTING OF SURFACES COATED W/THIS PRODUCT.
Ingred Name:STRONTIUM CHROMATE(SARA III)
OSHA PEL:0.1 PPM CRO3;CEILING
Ingred Name:SILICATE, MICA; (SILICEOUS MUSCOVITE MICA)
Fraction by Wt: <5%
Ingred Name:TITANIUM DIOXIDE
Fraction by Wt: <5%
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:XYLENE. VP:9.5
Ingred Name:SUPP DATA:NOTICE:INTENTIONAL MISUSE BY DELIBERATE CONC &
LEUCOCYTE DISORDERS WHICH MAY RESULT IN AN ANEMIC CONDITION.
Ingred Name:ACETIC ACID, BUTYL ESTER; (BUTYL ACETATE). VP:8
Ingred Name:BUTYL ALCOHOL; (N-BUTYL ALCOHOL). VP:4.4
Fraction by Wt: <5%
Ingred Name:CYCLOHEXANONE. VP:3.3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EXCESSIVE VAP CONC IN AIR, ESP
IN CONFINED SPACES, MAY CAUSE ASPHY. EXCESSIVE INHAL OF VAP CAN
CAUSE NASAL, THROAT & RESP IRRIT, DIZZ, WEAK, FATIGUE, NAUS, HDCH &
POSS UNCON. EYE CONT W/LIQ/VAP CAUSES SEV IRRIT, REDNESS, TEARING,
BLURRED VISION & A SENSATION OF SEEING HALOS AROUND LIGHTS. PRLNGD
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:STRONTIUM CHROMATE: GROUP 1 (IARC);
GROUP 1 (NTP)
Effects of Overexposure:HLTH HAZ:SKIN CONT MAY LEAD TO EXTRACTION OF
NATURAL OILS W/RESULTANT DRY SKIN, CRACKING, IRRIT, DERM, REDNESS &
ITCHING. MAY BE ABSORBED THRU SKIN. SWALLOWING MAY CAUSE GI IRRIT,
NAUS, VOM & DIARR. A SPIR OF MATL INTO LUNGS MAY CAUSE CHEM PNEUM,
WHICH CAN BE FATAL. SANDING DUST/DRY SPRAY MAY CAUSE IRRIT TO (SUPP
DATA)
Medical Cond Aggravated by Exposure:NONE EXPECTED.
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF
NECESSARY. SKIN:WASH W/SOAP & WATER. EYE:FLUSH W/WATER FOR AT LEAST
DILUTE. D O NOT INDUCE VOMITING. CONSULT MD OR POISON CONTROL
CENTER IMMEDIATELY. TREAT SYMPTOMATICALLY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1%
Extinguishing Media:FOAM, CARBON DIOXIDE & DRY CHEMICALS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER MAY BE INEFFECTIVE. WATER SHOULD BE
USED TO COOL CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT, SPARKS, ELEC EQUIP & OPEN FLAME. CLSD CONTRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATN TO HOT (SUPP DATA)
* Accidental Release Measures *
Spill Release Procedures:REFER TO PROTECTIVE MEASURES. REMOVE ALL
SOURCES OF IGNITION. AVOID BREATHING VAPORS. VENTILATE AREA. REMOVE
W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE CONTRS OUT OF SUN & AWAY FROM
HEAT, SPARKS & OPEN FLAMES. CLOSE CONTRS AFTER EACH USE. CONSULT
NFPA CODE FOR ADDNL STORAGE REQUIREMENTS.
Other Precautions:DO NOT TAKE INTERNALLY. USE APPRVD BONDING/GROUNDING
PROC. OBSERVE LBL PRECS. KEEP CLOSURES TIGHT & CONTR UPRIGHT TO
PVNT LEAKAGE. NEVER USE PRESS TO EMPTY. DRUM IS NOT A PRESS VESSEL.
* Physical/Chemical Properties *
HCC:F3
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, SMOKE
& OXIDES OF NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN AN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE W/FEDERAL,
STATE & LOCAL POLLUTION CONTROL REQUIREMENTS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:REQUIRED
Ventilation:USE W/ADEQUATE VENTILATION
Other Protective Equipment:IMPERVIOUS CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: MAY CAUSE SEVERE
IRRITATION/BURNS. INGESTION: MAY CAUSE IRRITATION & BURNS TO THE
MOUTH & STOMACH. HARMFUL IF INHALED/ABSORBED THROUGH SKIN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
* First Aid Measures *
First Aid:INGESTION: DON'T INDUCE VOMITING. IF CONSCIOUS, GIVE LARGE
AMOUNTS OF WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN
MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR PROPER PROTECTIVE EQUIPMENT & SELF
CONTAINED BREATHING APPARATUS W/FULL FACEPIECE OPERATED IN POSITIVE
PRESSURE MODE.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:WEAR SELF CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE CLOTHING. STOP LEAK SAFELY W/O RISK. VENTILATE AREA.
CAREFULLY NEUTRALIZE LEAK W/DILUTE HYDROGEN CHLORIDE. FLUSH AREA
W/FLOODING AMOUNTS OF WA TER. USE CAUTION.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA. DON'T GET IN EYES,
ON SKIN/ON CLOTHING.
Other Precautions:WHEN HANDLING LIQUID PRODUCTS, SECONDARY PROTECTIVE
CONTAINERS MUST BE USED FOR CARRYING. MATERIAL SHOULD BE HANDLED
ONLY BY A PERSON TRAINED IN/SUPERVISED BY A PERSON TRAINED IN,
CHEMICAL HANDLING. A VOID CONTACT & BREATHING OF VAPORS/FUMES
* Physical/Chemical Properties *
HCC:B3
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID W/NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED. IF EXPOSURE EXCEEDS
LIMITS USE A NIOSH-APPROVED RESPIRATOR TO PREVENT OVEREXPOSURE. USE
EITHER AN ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AIR-PURIFYING
RESPIRATOR FOR ORGANIC VAP ORS AND PARTICULATES.
Ventilation:PROVIDE ADEQUATE MECHANICAL VENTILATION/LOCAL EXHAUST
VENTILATION TO MAINTAIN EXPOSURE BELOW THE RECOMMENDED LIMITS.
Other Protective Equipment:WEAR CHEMICAL RESISTANT PROTECTIVE CLOTHING
AS REQUIRED TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SOLVENT REFINED, HYDROTREATED HEAVY PARAFFINIC DISTILLATE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 OIL MIST
Ingred Name:SOLVENT REFINED, RESIDUAL OIL
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 OIL MIST
Ingred Name:SOLVENT REFINED, CATALYTIC DEWAXED
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 OIL MIST
Ingred Name:ADDITIVE PACKAGE
Fraction by Wt: <4% VOL
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MINIMALLY IRRITATING. SKIN:
MILDLY IRRITATING. PROLONGED/REPEATED CONTACT MAY CAUSE DERMATITIS,
FOLLICULITIS, OIL ACNE. INHALATION: VAPOR (GENERATED AT HIGH
TEMPERATURES) OR OIL MIST MAY RESULT IN MILD IRRITATION OF UPPER
RESPIRATORYTRACT. INGESTION: SLIGHTLY TOXIC IF INGESTED.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION, DERMATITIS,
FOLLICULITIS, OIL ACNE. INHALATION: IRRITATION OF UPPER RESPIRATORY
TRACT. INGESTION: SLIGHTLY TOXIC.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH AREA WITH SOAP AND WATER. IF IRRITATION DEVELOPS, GET MEDICAL
ATTENTION. IN HALATION: MOVE TO FRESH AIR. PROVIDE OXYGEN/CPR IF
NEEDED. GET MEDICAL ATTENTION IF NEEDED. INGESTION: DO NOT INDUCE
VOMITING. GENERALLY NOT NEEDED UNLESS LARGE AMOUNTS INGESTED.GET
MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
DO NOT USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND
REIGNITE
Fire Fighting Procedures:MATERIAL WILL NOT BURN UNLESS PREHEATED. COOL
FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:DO NOT ENTER CONFINED FIRE-SPACE WITHOUT
BOOTS, POSITIVE PRESSURE NIOSH-APPROVED SCBA.).
* Accidental Release Measures *
Spill Release Procedures:MAY BURN BUT NOT READILY IGNITABLE. STOP LEAK.
DIKE AND CONTAIN SPILL. REMOVE FREE LIQUID WITH VACUUM TRUCKS OR
PUMP TO SALVAGE VESSEL. SOAK UP RESIDUE WITH ABSORBENT. FLUSH AREA
WITH WATER TO REMOVE TRACE RESIDUE. ABSORB SMALL SPILLS
WITHABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
PLACE AWAY FROM OPEN FLAMES, HIGH TEMPERATURES, OXIDIZING
MATERIALS..
Other Precautions:MINIMIZE SKIN CONTACT. DO NOT BREATHE MISTS OR
VAPORS. DO NOT GET IN EYE, OR ON CLOTHING. AVOID WATER
CONTAMINATION.
* Physical/Chemical Properties *
HCC:V6
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK AMBER OIL. SLIGHT HYDROCARBON ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:HEAT, OPEN FLAMES.
Hazardous Decomposition Products:AIRBORNE SOLID, LIQUID, PARTICULATES,
GASES, CARBON MONOXIDE, CARBON DIOXIDE, OTHER UNIDENTIFIED ORGANIC
COMPOUNDS.
Conditions to Avoid Polymerization:WILLN N0T OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DO NOT PERMIT DISCHARGE TO SEWERS, DRAINS,
STREAMS, WATERWAYS, OR EXTENDED LAND AREAS. REPORT SPILLS THAT MAY
ENTER SURFACE WATERS, WATER COURSES, TO NATIONAL RESPONSE CENTER.
DISPOSE OF WASTE IN ACC ORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:NORMAL ROOM VENTILATION
Supplemental Safety and Health
* Product Identification *
Product ID:SKLEEN
* Composition/Information on Ingredients *
Ingred Name:CONTAINS NO HAZARDOUS INGREDIENTS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
* First Aid Measures *
PHYSICIAN.SKIN:PROLONGED EXPOSURE TO THE UNDILUTED PRODUCT MAY
PRODUCE DERMAL IRRITATION.FLUSH SKIN THOROUGHLY WITH
WATER.INHALATION:REMOVE TO FRESH AIR AND CONTACT A
PHYSICIAN.INGESTION:IF SWALLOWED,DO NOT INDUCE VOMITING.DRINK LARGE
QUANTITIES OF WATER.CALL A PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:WATER,CO2,FOAM,DRY CHEMICAL
* Accidental Release Measures *
Spill Release Procedures:THIS IS A BIODEGRADABLE DETERGENT,CLEAN UP
SPILLS WITH WATER.
*Handling and Storage *
Handling and Storage Precautions:WILL WITHSTAND OCCASIONAL ACCIDENTAL
FREEZING.MUST BE THOROUGHLY THAWED AND AGITATED(ROLL DURM)BEFORE
DEING USED.
Other Precautions:READ AND OBSERVE LABELLED USE INSTRUCTIONS.
* Physical/Chemical Properties *
Solubility in Water:COMPLETE
Appearance and Odor:AMBER LIQUID MILD,PLEASANT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:FORCED IGNITION OF DRIED RESIDUES MAY
PRODUCE CO,CO2 AND SULFUR OXIDES.
* Disposal Considerations *
Waste Disposal Methods:SEWER SPENT SOLUTIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Supplemental Safety and Health
* Product Identification *
Product ID:FLOOR AND TRIM VARNISH
Preparer's Name:CHARLES FRIEDMAN
* Composition/Information on Ingredients *
Ingred Name:MINERAL SPIRITS
Other REC Limits:NONE SPECIFIED
Ingred Name:SOLVENT NAPTHA (PETROLEUM)
Fraction by Wt: *
Other REC Limits:*PROPRIETARY
Ingred Name:SOYBEAN OIL POLYMER
Fraction by Wt: *
Other REC Limits:*PROPIETARY
Ingred Name:LINSEED OIL BODIED
Fraction by Wt: *
Other REC Limits:*PROPRIETARY
Ingred Name:TUNG OIL, BODIED
Fraction by Wt: *
Other REC Limits:*PROPRIETARY
Fraction by Wt: *
Other REC Limits:*PROPIETARY
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1
Upper Limits:6
Extinguishing Media:WATER FOG, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:FULL BUNKER GEAR (HELMET WITH FACE SHIELD,
APPROVED SELF- CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COOL FIRE EXPOSED CONTAINERS WITH WATER.
DO NOT USE DIRECT STREAM OF WATER ON POOL FIRES, PRODUCT WILL FLOAT
AND CAN BE REIGNITED ON SURFACE OF WATER.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:>AIR
Viscosity:C-H
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW LIQUID, PETROLEUM ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS LIQUID CHLORINE, CONCENTRATED OXYGEN,
SODIUM OR CALCIUM HYPOCHLORITE.
Stability Condition to Avoid:HEAT, FLAME.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN OUTDOOR/OPEN AREAS, W/UNRESTRICTED VENT, USE
A NIOSH/MSHA APPRVD FILTER RESP TO REMOVE SOLID AIR-BORNE PARTICLES
OF OVERSPRAY DURING SPRAY APPLICATION. IN RESTRICTED VENT AREAS,
Ventilation:PROVIDE SUFFICIENT VENT, IN VOL & PATTERN, TO KEEP TLV &
LEL OF HAZ INGRED BELOW LIM, & TO REMOVE DECOMP (SUPP DATA)
Other Protective Equipment:WEAR APPROPRIATE IMPERVIOUS PROTECTIVE
CLOTHING TO PREVENT SKIN CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: BE USED AS AN EXTING MEDIA. TAKE CARE TO PVNT SPREAD
OF BURNING LIQ W/WATER. CLSD CONTRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. RESP PROT: TO REMOVE A COMBINATION OF PARTICULATES &
VAPS. VENT: PROD DURING WELD/FLAME CUTTING ON SURF COATED W/PROD.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:LIGROINE; (VM&P NAPHTHA). VP: 7
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CAN CAUSE IRRIT WITH
REDNESS, TEARING & BLURRED VISION. SKIN: IRRITATING. MAY RESULT IN
DERMATITIS. INHAL: IRRITATION OF RESPIRATORY TRACT. HEADACHE &
DIZZINESS & UNCONSCIOUSNESS. INGEST: MAY CAUSE GI IRRITATION.
CHRONIC OVEREXP TO, AND MISUSE OF, SOLV HAS BEEN LINKED TO PERM
BRAIN & NERV SYS DAM.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
MINUTES. GET MEDICAL ATTENTION IMMED. SKIN: REMOVE CONTAMINATED
CLOTHING, WASH SKIN WITH PLENTY OF SOAP AND WATER. LAUNDER CLOTHES
BEFORE RE USE. INHAL: REMOVE TO FRESH AIR. GIVE ARTF RESP IF
NEEDED. GET MEDICAL ATTENTION. INGEST: CALL A PHYSICIAN IMMED TO
DETERMINE WHETHER OR NOT TO INDUCE VOMITING.
* Fire Fighting Measures *
Lower Limits:1%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
SMOTHER FLAMES W/ONE OF ABOVE EXTING MEDIA. WATER MAY BE USED TO
COOL UNOPENED CONTRS, BUT MUST NOT (SUPP DATA)
Unusual Fire/Explosion Hazard:CONTAINS FLAMMABLE SOLVENT. DO NOT USE IN
AREAS WHERE SPARK OR OPEN FLAME ARE PRESENT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT. AVOID PROLONGED
INHAL OF VAPORS. VENTILATE AREA. CLEAN UP WITH ABSORBENT MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN BLDG DESIGNED & PROTECTED FOR
STOR OF LIQS W/NFPA CLASS GIVEN BY OSHA CLASS. AVOID BRTHG HIGH
DUST/CHIPS FROM SAND/BLAST SURF COATED W/PROD.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:STORE AWAY FROM DIRECT HEAT, FLAME/SPARK.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
VARIOUS HYDROCARBON FRAGMENTS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS. DO NOT INCINERATE UNOPENED CONTAINERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A RESPIRATORY PROTECTION PROGRAM THAT MEETS
OSHA'S REQUIREMENTS MUST BE FOLLOWED WHENEVER WORKPLACE CONDITIONS
WARRANT A RESPIRATOR'S USE.
Ventilation:REQUIRED TO KEEP AIRBORNE CONCENTRATIONS LOW.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:1,3-PROPANEDIOL , 2-AMINO-2-(HYDROXYMETHYL), TROMETHAMINE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION & POSSIBLE INJURY.
SKIN: IRRITATION, DERMATITIS & BURNS. INGESTION: MAY CAUSE SEVERE
GI TRACT IRRITATION & POSSIBLE BURNS. INHALATION: MAY CAUSE
IRRITATION OF THE RESPIRATORY TRACT & BURNS TO THE NOSE, THROAT &
PULMONARY EDEMA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNS, NAUSEA, VOMITING, COUGHING,
WHEEZING, SHORTNESS OF BREATH.
* First Aid Measures *
ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. NEVER GIVE ANYTHING BY MOUTH
TO AN UNCONSC IOUS PERSON. INHALATION: REMOVE TO FRESH AIR. GIVE
CPR/OXYGEN IF NEEDED. OBTAIN MEDICAL ATTENTION IN ALL CASES. NOTES
TO PHYSICIAN: TREAT SYMPTOMATICALLY & SUPPORTIVELY.
* Fire Fighting Measures *
Extinguishing Media:WATER, DRY CHEMICAL, CHEMICAL FOAM/ALCOHOL
RESISTANT FOAM.
Fire Fighting Procedures:WEAR SCBA IN PRESSURE DEMAND, MSHA/NIOSH
APPROVED/EQUIVALENT & FULL PROTECTIVE GEAR.
* Accidental Release Measures *
Spill Release Procedures:USE PERSONAL PROTECTIVE EQUIPMENT. CLEAN UP
IMMEDIATELY, OBSERVE PRECAUTIONS. SWEEP UP, THEN PLACE INTO A
SUITABLE CLEAN, DRY CONTAINER FOR DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP AWAY
FROM ACIDS. KEEP CONTAINERS TIGHTLY CLOSED. USE W/ADEQUATE
VENTILATION.
Other Precautions:AVOID CONTACT W/EYES, SKIN & CLOTHING. AVOID
INGESTION & INHALATION.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:(SEE SUPP)
Solubility in Water:MODERATELY
Appearance and Odor:FINE, SOLID WHITE CRYSTALLINE POWDER, DELIQUESCENT
W/ABINE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE MATERIALS, BASES, OXIDIZING AGENTS, ACIDS, ALDEHYDES,
COPPER, BRASS & ALUMINUM.
Hazardous Decomposition Products:NITROGEN OXIDES, CO, CO2, NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHEN EXPOSURE LIMITS ARE EXCEEDED, USE
APPROPRIATE APPROVED RESPIRATOR.
Ventilation:PROVIDE ADEQUATE LOCAL VENTILATION FOR CUTTING, GRINDING,
WELDING OR MELTING.
ABRASIONS & IRRITATION.
SHOULD BE USED.
Other Protective Equipment:PROTECTIVE CLOTHING SHOULD BE USED TO
PROTECT AGAINST SKIN BURNS, ABRASION & IRRITATION.
Supplemental Safety and Health
PRODUCT CLASS: METAL CASTINGS.
* Product Identification *
Product ID:HAST C, NICKEL BASE AIR MELT ALLOYS
Preparer's Name:JOHN HESLOP
* Composition/Information on Ingredients *
Ingred Name:SILICON
Fraction by Wt: 1% MAX
Ingred Name:VANADIUM
= Wt:.3
Ingred Name:TUNGSTEN
ACGIH TLV:5 MG/M3
Ingred Name:MOLYBDENUM
Ingred Name:ALUMINIUM
= Wt:.9
ACGIH TLV:5 MG/M3
Ingred Name:CHROMIUM
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COBALT
Fraction by Wt: 2.5% MAX
OSHA PEL:0.1 MG/M3
Ingred Name:CARBON
Ingred Name:IRON
= Wt:5.5
ACGIH TLV:5 MG/M3;2 PPM
Ingred Name:MANGANESE
Fraction by Wt: 1% MAX
OSHA PEL:C5 MG/M3
ACGIH TLV:2MG/M3
Ingred Name:NICKEL
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
* Hazards Identification *
Health Hazards Acute and Chronic:UNDER NORMAL CONDITIONS, EXPOSURE TO
ALLOY CASTINGS PRESENTS FEW HEALTH HAZARDS. EXCESSIVE INHALATION OF
DUST OR FUMES FROM GRINDING, CUTTING OR MELTING MAY PRESENT
POTENTIALLY SIGNIFICANT HEALTH HAZA RDS. EXCESSIVE INHALATION OF
NICKEL AND CHROMIUM FUMES HAS BEEN ASSOCIATED WITH RESPIRATORY
CANCER. NICKEL IS A POTENTIAL SENSITIZER AND MAY CAUSE ALLERGIC
REACTIONS.
Explanation of Carcinogenicity:NICKEL AND CHROMIUM HAVE BEEN A SUSPECT
CARCINOGEN BY NTP AND IARC.
* First Aid Measures *
First Aid:IF IRRITATION OCCURS, FLUSH EYES. WASH SKIN WITH WATER,
REMOVE AFFECTED PERSON TO FRESH AIR. SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:NOT FLAMMABLE. DRY CHEMICAL, SAND.
Fire Fighting Procedures:NONE REQUIRED.
Unusual Fire/Explosion Hazard:METAL IN BULK FORM IS NOT COMBUSTIBLE.
FIRE AND EXPLOSION HAZARDS EXIST ONLY WHEN DUST PARTICLES ARE
EXPOSED TO HEAT, FLAMES, STRONG OXIDIZERS OR CHEMICALS THAT SUPPORT
COMBUSTION.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:7.5-8.5
Appearance and Odor:GRAY METALLIC; NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZERS.
Stability Condition to Avoid:MOLTEN METAL WILL REACT VIOLENTLY WITH
WATER.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:RELATIVELY CLEAN METAL SHOULD BE RECYCLED AS
SCRAP ALLOY, OTHERWISE DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE
& LOCAL REGULATIONS.
* MSDS Transport Information *
Transport Information:DOT PROPER SHIPPING NAME: PAINT.
* Regulatory Information *
SARA Title III Information:THIS PRODUCT MAY CONTAIN ONE OR MORE OF THE
FOLLOWING ALLOYING ELEMENTS WHICH ARE SUBJECT TO THE REPORTING
CHROMIUM, COBALT, COPPER, MANGANESE, NICKEL, VANADIUM. PLEASES
REFER TO THE HAZARDOUS INGREDIENTS SECTION OF THIS MSDS FOR THE
APPROPIATE CAS NUMBER AND PERCENT BY WEIGHT.
State Regulatory Information:
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH-APPROVED RESPIRATORY EQIPMENT WHEN
CONCENTRATION OF VAPOR/MIST EXCEEDS APPLICABLE EXPOSURE LIMIT.DO
NOT USE N-RATED RESPIRATORS. SCBA AND FULL PROTECTIVE EQUIPMENT
REQUIRED FOR FIRE EMERGENC IES. EQUIPMENT SHOULD BE IN ACCORDANCE
Ventilation:PROVIDE VENT NEEDED TO MAINTAIN CONCENTRATION OF VAPOR/MIST
BELOW APPLICABLE EXPOSURE LIMIT. IF ADEQUATE VENT UNAVAILABLE--SEE
BELOW
Other Protective Equipment:WEAR CHEMICAL-RESISTANT APRON,BOOTS,OTHER
PROTECTIVE CLOTHING TO AVOID PROLONGED/REPEATED CONTACT.EMERGENCY
EYEWASH IN IMMEDIATE AREA. CLEAN WATER SHOULD BE AVAILABLE FOR
FLUSHING EYES AND SKIN.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
USE PROCESS ENCLOSURES,LOCAL EXHAUST VENTILATION,OR OTHER ENGINEERING
CONTROLS TO CONTROL AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE
LIMITS.
* Product Identification *
Preparer's Name:PRODUCT MSDS COORDINATOR
* Composition/Information on Ingredients *
Ingred Name:LUBRICATING OILS (PETROLEUM), HYDROTREATED SPENT
Ingred Name:RESIDUAL OILS (PETROLEUM), SOLVENT-DEWAXED
Minumum % Wt:0.
Ingred Name:RESIDUAL OILS (PETROLEUM), HYDROTREATED
Minumum % Wt:0.
STOCK-BASED
Minumum % Wt:0.
Ingred Name:MINERAL OIL
Minumum % Wt:0.
Ingred Name:ADDITIVES
Minumum % Wt:0.
Maxumum % Wt:9.
Ingred Name:DISTILLATES (PETROLEUM), HYDROTREATED HEAVY PARAFFINIC
Minumum % Wt:0.
Maxumum % Wt:6.
Ingred Name:DISTILLATES (PETROLEUM), SOLVENT-DEWAXED HEAVY PARAFFINIC
Minumum % Wt:0.
Maxumum % Wt:6.
Ingred Name:ALKARYL AMINE
Minumum % Wt:0.
Maxumum % Wt:2.
Ingred Name:BENZENAMINE, N-PHENYL-, REACTION PRODUCTS WITH
2,4,4-TRIMETHYLPENTENE
Minumum % Wt:0.
Maxumum % Wt:1.5
SALTS
Minumum % Wt:0.
Maxumum % Wt:1.5
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED OR REPEATED INHALATION OF
OIL MIST MAY CAUSE PNEUMONIA, LUNG TISSUE INFLAMMATION, AND/OR
FIBROUS TISSUE FORMATION. PROLONGED OR REPEATED EYE CONTACT MAY
CAUSE INFLAMMATION OF THE MEMBRANE LI NING THE EYELIDS AND COVERING
THE EYEBALL (CONJUNCTIVITIS). PROLONGED OR REPEATED SKIN CONTACT
MAY CAUSE DRYING, CRACKING, REDNESS, ITCHING, AND/OR SWELLING
(DERMATITIS).
Explanation of Carcinogenicity:NO KNOWN CARCINOGENICITY. NO ANIMAL SKIN
CARCINOGENICITY TESTS OF THESE MATERIALS HAVE BEEN CONDUCTED.
NEITHER IARC, NTP, ACGIH, NOR OSHA HAVE CLASSIFIED THESE MATERIALS
AS TO THEIR CARCINOGENIC RISK.
Effects of Overexposure:INHALATION-HIGH CONCENTRATIONS OF VAPOR OR MIST
MAY IRRITATE THE RESPIRATORY TRACT (NOSE, THROAT, AND LUNGS).
EYES-BRIEF, DIRECT CONTACT WITH PRODUCT MAY CAUSE IRRITATION.
SKIN-BRIEF, DIRECT CONTACT W ITH PRODUCT MAY CAUSE IRRITATION. A
SINGLE, PROLONGED EXPOSURE IS NOT LIKELY TO CAUSE THE PRODUCT TO BE
ABSORBED THROUGH THE SKIN IN HARMFUL AMOUNTS. INGESTION-MAY CAUSE
THROAT IRRITATION, NAUSEA, VOM ITING AND DIARRHEA. BREATHING
PRODUCT INTO LUNGS DURING INGESTION OR VOMITING MAY CAUSE LUNG
INJURY AND POSSIBLE DEATH.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING,
RESPIRATORY TRACT (NOSE, THROAT AND LUNGS), EYE, AND/OR SKIN
DISORDERS MAY HAVE INCREASED SUSCEPTIBILITY TO THE EFFECTS OF
EXPOSURE.
* First Aid Measures *
First Aid:INHALATION-REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE CPR.
IF BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION.
IRRITATION/RE DNESS DEVELOPS, MOVE AWAY FROM EXPOSURE. GET MEDICAL
ATTENTION. SKIN-REMOVE CONTAMINATED CLOTHING/SHOES. WASH SKIN
THOROUGHLY WITH SOAP & WATER. GET MEDICAL ATTENTION. IF PRODUCT IS
INJECTED UNDER PRE SSURE INTO/ UNDER THE SKIN, A PHYSICIAN SHOULD
IMMEDIATELY EVALUATE THE INDIVIDUAL. INGESTION-IMMEDIATELY GET
MEDICAL ATTENTION. DO NOT INDUCE VOMITING. IF SPONTANEOUSLY OCCURS,
KEEP HEAD BELOW HIPS T O AVOID BREATHING PRODUCT INTO LUNGS.
* Fire Fighting Measures *
Flash Point Method:COC
Lower Limits:1 VOL%
Extinguishing Media:CARBON DIOXIDE, REGULAR FOAM, DRY CHEMICAL, WATER
SPRAY, OR WATER FOG
Fire Fighting Procedures:KEEP STORAGE CONTAINERS COOL WITH WATER SPRAY.
POSITIVE-PRESSURE SELF-CONTAINED BREATHING APPARATUS AND STRUCTURAL
FIREFIGHTERS' PROTECTIVE CLOTHING MAY PROVIDE LIMITED PROTECTION.
Unusual Fire/Explosion Hazard:HEATED CONTAINERS MAY RUPTURE. "EMPTY"
CONTAINERS MAY RETAIN RESIDUE AND CAN BE DANGEROUS. NOT SENSITIVE
TO MECHANICAL IMPACT OR STATIC DISCHARGE.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. DO NOT TOUCH OR
WALK THROUGH SPILLED PRODUCT. STOP LEAK IF YOU CAN. WEAR PROTECTIVE
EQUIPMENT. ISOLATE HAZARD AREA. KEEP UNNECESSARY/UNPROTECTIVE
PERSONNEL AWAY. VENTILATE AREA & AVOID VAPOR/MIST. CONTAIN FROM
SURFACE WATERS/SEWERS. CONTAIN AS A LIQUID FOR POSSIBLE RECOVERY OR
SORB WITH COMPATIBLE MATERIAL & SHOVEL WITH A CLEAN TOOL INTO A
SEALABLE DISPOSAL CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED WHEN NOT
IN USE AND DURING TRANSPORT. STORE CONTAINER IN A COOL, DRY PLACE.
DO NOT PRESSURIZED, CUT, WELD, BRAZE, SOLDER, DRILL OR GRIND. KEEP
CONTAINERS AWAY FROM HEAT,FLAME, SPARKS OR OTHER SOURCES OF
IGNITION.
Other Precautions:EMPTY PRODUCT CONTAINERS MAT RETAIN PRODUCT RESIDUE
AND CAN BE DANGEROUS. HANDLING_USE CLEAN TOOLS. THIS PRODUCT HAS A
LOW VAPOR PRESSURE AND IS NOT EXPECTED TO PRESENT AN INHALATION
HAZARD UNDER NORM AL TEMPERATURES AND PRESSURES. HOWEVER, WHEN
AEROSOLIZING OR MISTING THIS PRODUCT, DO NOT BREATHE VA POR OR
MIST.
* Physical/Chemical Properties *
HCC:N1
M.P/F.P Text:POUR POINT
Solubility in Water:INSOLUBLE
Appearance and Odor:LIQUID, AMBER, PETROLEUM ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID OXIDIZING AGENTS
Stability Condition to Avoid:AVOID HEAT, SPARKS, FLAME
Hazardous Decomposition Products:NONE UNDER NORMAL TEMPERATURES AND
PRESSURES. SEE HAZARD COMBUSTION PRODUCTS SECTION.
* Toxicological Information*
Toxicological Information:SENSITIZATION: NO KNOWN HUMAN SENSITIZATION.
REPRODUCTIVE TOXICITY: NO KNOWN REPRODUCTIVE TOXICITY.
TERATOGENICITY: NO KNOWN TERATOGENICITY. MUTAGENICITY: NO KNOWN
MUTAGENICITY. TOXICOLOGICALLY SYNERG ISTIC PRODUCTS: NO KNOWN
TOXICOLOGICALLY SYNERGISTIC PRODUCTS ASSOCIATED WITH THIS PRODUCT.
CARCINOGENICTY: NO ANIMAL SKIN CARCINOGENICITY TESTS OF THESE
MATERIALS HAVE BEEN CONDUCTED. NEITHER IARC, NTP, ACGIH NOR OSHA
HAVE CLASSIFIED THESE MATERIALS AS TO THEIR CARCINOGENIC RISK.
* Ecological Information *
Ecological:ECOTOXICITY: NOT AVAILABLE. OCTANOL/WATER PARTITION
COEFFICIENT: NOT AVAILABLE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE,
PROVINCIAL AND LOCAL REGULATIONS. REGULATIONS MAY ALSO APPLY TO
EMPTY CONTAINERS. THE RESPONSIBILITY FOR PROPER DISPOSAL LIES WITH
THE OWNER OF THE WASTE. CO NTACT SAFETY-KLEEN REGARDING RECYCLING
OR PROPER DISPOSAL.
* MSDS Transport Information *
Transport Information:DOT: NOT REGULATED. TDG: THIS PRODUCT IS NOT FOR
USE OR SALE IN CANADA.
* Regulatory Information *
Federal Regulatory Information:ALL COMPONENTS OF THIS PRODUCT ARE
LISSTED ON OR ARE EXEMPTED FROM THE REQUIREMENT TO BE LISTED ON,
THE TSCA INVENTORY.
State Regulatory Information:THIS PRODUCT CONTAINS ACETALDEHYDE, CAS
THIS PRODUCT MAY HAVE DETECTABLE AMO UNTS OF BENZO(A)ANTHRACENE,
CALIFORNIAAS KNOWN CARCINOGENS. MANUFACTURER'S TESTING INDICATES
THEY ARE NOT ALWAYS DETECTABLE.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR DUST/MIST
IF CONCENTRATION>TL
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
* Product Identification *
Product ID:MAGNESIUM CHLORIDE
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of Overexposure:EYES:IRRITATION;SKIN:IRRITATION;INHAL:IRRIT.OF
NASAL AND RESP.TRACT,INGEST:G.I.IRRIT,NAUSEA VOMITING
* First Aid Measures *
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE.
* Fire Fighting Measures *
Extinguishing Media:WATER FOG,CO*2,FOAM,DRY CHEMICAL
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA IN CONFINED AREA.
Unusual Fire/Explosion Hazard:NONE NOTED
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;SWEEP UP OR
SHOVEL MATERIAL INTO A CONTAINERS;THOROUGHLY SWEEP AREA OF SPILL TO
CLEAN UP ANY RESIDUAL MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL DRY AREA;KEEP CONTAINER
TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:AVOID CONTACT WITH EYES AND SKIN:DO NOT BREATHE
DUST/MIST.WASH AFTER EACH USE.
* Physical/Chemical Properties *
HCC:N1
Appearance and Odor:WHITE CRYSTALS,ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
METALS
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:NONE NOTED
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:COBALT (SARA III)
OSHA PEL:0.1 MG/M3;AS CO
* Accidental Release Measures *
* Physical/Chemical Properties *
HCC:A2
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF THE TLV OF ANY COMPONENT IS EXCEEDED, A
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED IN ABSENCE
OF PROPER ENVIRONMENTAL CONTROLS.
Ventilation:PROVIDE SUFFICIENT VENTILATION (EXPLOSION PROOF) TO
MAINTAIN EXPOSURE BELOW THE TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
IMPERVIOUS CLOTHING AND BOOTS IF NEEDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
DO NOT WEAR CONTACT LENSES. EMPTY CONTAINERS MAY CONTAIN HAZARDOUS
PRODUCT RESIDUES AND CONSTITUTE HAZARDOUS WASTE. DISPOSE OF EMPTY
CONTAINERS IN COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
* Product Identification *
Preparer's Name:JOHN C.FUNK
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM DISTILLATE, MINERAL SPIRITS, (NAPHTHA, MEDIUM
ALIPHATIC)
Ingred Name:ALKYD PHENOLIC RESIN
Other REC Limits:NONE SPECIFIED
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES AND MUCOUS
MEMBRANES, CHEMICAL PNEUMONITTA, PULMONARY EDEMA/HEMORRHAGE, AND
DEPRESSION OF CENTRAL NERVOUS SYSTEM.
Effects of Overexposure:EYE IRRITATION, IRRITAION OF MUCOUS MEMBRANES,
DRY SKIN, HEADACHE, DIZZINESS, NAUSEA, OR LOSS OF CONXCIOUSNESS.
Medical Cond Aggravated by Exposure:PERSONS WITH EXISTING EYE, SKIN,
AND RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE TO
THIS PRODUCT.
* First Aid Measures *
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. IF IRRITATION
PERSISTS GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH AREA WITH SOAP AND WATER. GET MEDICAL ATTENTION IF IRRITATION
DEVELOPS. INHALATION: MOVE TO FRESH AIR. IF NOT BREATHING GIVE
CPR. IF BREATHING DIFFICULT GIVE OXYGEN. GET MEDICAL ATTENTION.
INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:FOAM, CARBON DIOXIDE, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR SCBA WITH A FULL FACEIECE OPERATED IN
PRESSURE-DEMAND MODE WHEN FIGHTING FIRES. USE WATER TO COOL FIRE
EXPOSED CONTAINERS, EQUIPMENT, OR STRUCTURES.
Unusual Fire/Explosion Hazard:A DIRECT WATER STREAM MAY SPREAD BURNING
PRODUCT. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL ALONG GROUND TO
DISTANT IGNITION SOURCE AND BACKFLASH.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. WEAR PROPER
PROTECTION EQUIPMENT. VENTILATE THE AREA. PREVENT RUN-OFF INTO
SEWERS, STREAMS, OR OTHER BODIES OF WATER. ABSORB IN INERT MATERIAL
AND PLACE IN APPROPIATE D ISPOSAL CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS
AWAY FROM HEAT, SPARKS, AND OPEN FLAME. CONTAINERS SHOULD BE
GROUNDED WHEN TRANSFERRING.
Other Precautions:NEVER USE PRESSURE TO EMPTY. LOOSEN CLOSURES
CAREFULLY. EMPTY CONTAINERS MAY CONTAIN HAZARDOUS RESIDUES. NEVER
USE WELDING OR CUTTING TORCHES ON OR NEAR CONTAINERS (EVEN EMPTY)
BECAUSE PRODUCT (OR RES IDUE) CAN IGNITE EXPLOSIVELY.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:2
Vapor Density:>1, AIR=1
Evaporation Rate & Reference:0.7 (ETHYL ETHER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID. PETROLEUM DISTILLATE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING MAY PRODUCE CARBON MONOXIDE
AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. MANUFACTURER RECOMMENDS DISPOSING BY
INCINERATION IF PERMITTED.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE SUPPLIED-AIR RESPIRATOR PROTECTION IN
CONFINED OR ENCLOSED AREA
REL.
Other Protective Equipment:FACE SHIELD,CHEMICAL RESISTANT APRON OR
OTHER PROTECT.CLTHG.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
ADDITIVES) TLV AS OIL MIST.
ACGIH TLV:5MG/CUM(OILMIST
* Hazards Identification *
Effects of Overexposure:PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE
MILD SKIN IRRITATION,DIZZINESS,SUFFOCATION,IRR.EYES.
* First Aid Measures *
First Aid:MOVE VICTIM TO FRESH AIR;CALL EMERGENCY MEDICAL CARE.IF NOT
BREATHING,GIVE ARTIFICAL RESPIRATION.IF BREATHING IS DIFFICULT,GIVE
OXYGEN.IN CASE OF CONTACT WITH MATERIAL,IMMEDIATELY FLUSH SKIN &
* Fire Fighting Measures *
Lower Limits:1.0
Extinguishing Media:FOAM,DRY CHEMICAL,CO*2,OR WATER FOG OR SPRAY
Fire Fighting Procedures:USE AIR-SUPPLIED BREATHING EQUIP.COOL EXPD
CONTS W/H*2O SPRA
Unusual Fire/Explosion Hazard:DO NOT MIX OR STORE W/STRONG OXIDANTS
LIKE LIQ.CL*2 OR CONC.O*2
* Accidental Release Measures *
Spill Release Procedures:REMOVER FREE LIQUID.KEEP PETROLEUM PRODUCTS
OUT OF SEWERS & WATERCOURSES BY DIKING OR IMPOUNDING.ADVISE
AUTHORITIES IF PRODUCT HAS ENTERED OR MAY ENTER SEWERS,WATERCOURSES
OR EXTENS.LAND AREAS.ELIM.IG N.SOURCES.STOP LEAK.ABS W/COMML
ABS.PROV.VENTL.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE.DO NOT HANDLE OR STORE NEAR HEAT,SPARKS,FLAMES OR STRONG
OXIDANTS.AVOID BREATHING OIL MIST.
Other Precautions:REMOVE OIL SOAKED CLOTHING AND LAUNDER BEFORE
REUSE.DISCARD OIL SOAKED SHOES.WASH SKIN THOROUGHLY WITH SOAP AND
WATER AFTER HANDLING.
* Physical/Chemical Properties *
HCC:V6
Vapor Pres:0.0
Solubility in Water:NEGLIGIBLE
Appearance and Odor:STRAW COLORED LIQUID,BLAND FATTY ODOR.
Percent Volatiles by Volume:0.0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS:CL*2,CONC O*2,SODIUM OR CALCIUM HYPOCHLORITE
Hazardous Decomposition Products:FUMES,SMOKE,CARBON MONOXIDE, & SULFUR
OXIDES,(INCOMP.COMBUST
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF ABSORBED MATERIAL AT AN APPROVED
WASTE DISPOSAL SITE OR FACILITY.KEEP IN COVERED DRUMS,PENDING
DISPOSAL.HANDLE & DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE,& LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .RESPIRATOR ORGANIC VAPORS.
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV
Other Protective Equipment:EYE WASH STATIONS AND SAFTY SHOWERS SHOULD
BE AVAILABLE.
Work Hygienic Practices:WASH HANDS AFTER USE,BEFORE EATING OR USING
WASHROOM.
Supplemental Safety and Health
WT/GAL:9.0.OTHER PRECAUTIONS:CUT OR PUNCTURE ON OR NEAR CNTNRS.
* Product Identification *
* Composition/Information on Ingredients *
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE OR SKIN CONTACT MAY CAUSE
DISCOMFORT BY DEFATTING ACTION OF SOLVENT.REPEATED SKIN CONTACT MAY
CAUSE DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION:TEMPORARY
DIZZINESS,HEADACHE,POSSIBLE NAUSEA;SYMPTOMS DISAPPEAR WHEN EXPOSURE
CEASES.EYES:DISCOMFORT.SKIN:DISCOMFORT;DERMATITIS FROM REPEATED
CONTACT.INGESTION:N/K .
Medical Cond Aggravated by Exposure:RESPIRATORY AND CARDIOVASCULAR.
* First Aid Measures *
First Aid:INHALATION:REMOVE PATIENT TO FRESH AIR.EYES:FLUSH WITH LARGE
REMOVE SATURATED CLOTHING.IF SYMPTOMS PERSIST,GET MEDICAL
ATTENTION.INGES TION:CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:0.7%
Upper Limits:N/K
Extinguishing Media:FOAM,CARBON DIOXIDE,DRY CHEMICAL,WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
.COOL EXPOSED CNTNRS W/ WATER SPRAY TO REDUCE PRESS.AVOID BRTHING
VAPORS.FIGHT AS VOLATILE LIQUID FIRE.
Unusual Fire/Explosion Hazard:KEEP AWAY FROM HEAT,SPARKS AND OPEN
FLAME.HAZARDOUS DECOMP PROD:CARBON DIOXIDE,CARBON MONOXIDE,POSSIBLE
ACROLEIN.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF IGNITION AND PROVIDE
VENTILATION.LARGE SPILLS:SCOOP UP WITH NON-SPARKING TOOLS.PROVIDE
RESPIRATORY PROTECTION IF REQUIRED.SMALL SPILLS:PICK UP WITH
ABSORBENT MATERIALS.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM HEAT,SPARKS,AND OPEN
FLAME.AVOID PROLONGED SKIN CONTACT.DO NOT BREATHE SPRAY MIST.
Other Precautions:GROUND CNTNRS WHEN POURING;KEEP FREE FALL < A FEW
INCHES TO PVNT STATIC SPARKS.AVOID SPONTANEOUS COMBUST OF CONTAMED
RAGS & EASILY IGNIT ORG ACCUM BY IMMED IMMERSION IN WATER.EMPTY
CNTNRS RETAIN HAZ P ROPERTIES.DO NOT WELD,(SEE SUPP DATA)
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:N/K
Appearance and Odor:N/K
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXTREME HEAT OR HIGH HUMIDITY.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE AND
POSSIBLE ACROLEIN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .PLACE IN CLOSED CONTAINERS FOR
DISPOSAL.INCINERATE OR USE SECURE LANDFILL.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION.WEAR A PROPERLY FITTED ORGANTIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION
AGAINST MATERIALS. W HEN SANDING OR ABRDING THE DRIED FILM, WEAR A
DUST/MIST RESPIRATOR UNDERLYING PAINT, OR THE ABRASIVE.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
EXPOSURE LIMITS.
FOR PROTECTION.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:ERNEST CARTER
* Composition/Information on Ingredients *
Ingred Name:MINERAL SPIRITS
Code:F
Minumum % Wt:5.
Ingred Name:TOLUENE
Minumum % Wt:.5
Maxumum % Wt:1.
OSHA PEL:SEE TABLE Z-2
Ingred Name:XYLENE
Minumum % Wt:.5
Maxumum % Wt:1.
Ingred Name:LIGHT AROMATIC SOLVENT NAPHTHA (PETROLEUM)
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:1,3,5-TRIMETHYLBENZENE
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:1,2,4-TRIMETHYLBENZENE
Minumum % Wt:3.
Maxumum % Wt:8.
Ingred Name:COBALTOUS 2-ETHYLHEXANOATE
Minumum % Wt:.1
Maxumum % Wt:.2
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:KAOLIN
Minumum % Wt:0.
ACGIH TLV:2 MG/M3
Ingred Name:TALC
Minumum % Wt:0.
Maxumum % Wt:5.
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:2 MG/M3
Ingred Name:CALCIUM CARBONATE
Minumum % Wt:5.
Ingred Name:TITANIUM DIOXIDE
Minumum % Wt:0.
Ingred Name:CARBON BLACK
Minumum % Wt:0.
Maxumum % Wt:5.
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EXPOSURE MAY BE BY INHALATION AND/OR
SKIN OR EYE CONTACT, DEPENDING ON CONDITIONS OF USE. TO MINIMIZE,
FOLLOW RECOMMENDATIONS FOR PROPER USE, VENTILATION,AND PERSONAL
PROTECTIVE EQUIPMENT.IRRITATION O F EYES, SKIN AND RESPIRATORY
SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION.EXTREME OVEREXPOSURE
MAY RESULT IN UNCONSCIOUSNESS AND POSSIBLY DEATH.
Effects of Overexposure:HEADACHE,DIZZINESS,NASEA,AND LOSS OF
COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO VAPORS OR
SPRAY MISTS.REDNESS AND ITCHING OR BURING SENSATION MAY INDICATE
EYE OR EXCESSIVE SKIN EXPOSURE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER.
REMOVE COMTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE. FLUSH EYES
GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:CALC
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS SHOULD BE USED. WATER SPRAY MAY
BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE. WATER
MAY BE USED TO COOL CLOSED CO NTAINERS TO PREVENT PRESSURE BUILD-UP
AND POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME
HEAT.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.APPLICATION TO
HOT SURFACES REQUIRES SPECIAL PRECAUTIONS.DURING EMERGENCY
CONDITIONS OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A
HEALTH HAZARD.L ATTENTION.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:CONTENTS ARE COMBUSTIBLE. KEEP AWAY
FROM HEAT AND OPEN FLAME. CONSULT NFPA CODE. USE APPROVED BONDING
AND GROUNDING. BROCEDURES. KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAI NERS WITH COMPLETE AND APPROPRIATE
LABELING. DO NOT TEKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.
* Physical/Chemical Properties *
Vapor Density:HEAVIER
Spec Gravity:1.1-1.4
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE
Conditions to Avoid Polymerization:WILL NOT OCCUR
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM THIS PRODUCT MAY BE HAZARDOUS AS
APPLICABLE EPA HAZARDOUS WASTE NUMBERS.
* Regulatory Information *
COMPOUND, .2% BY WEIGHT.
NOTIFICATION
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED. A RESPIRATOR SHOULD BE
WORN IF HAZARDOUS DECOMPOSITION PRODUCTS ARE LIKELY TO BE OR HAVE
BEEN RELEASED. RESPIRATOR TYPE: ACID GAS. SEE STABILITY AND
REACTIVITY SECTION. IF RESPI RATORS ARE USED, A PROGRAM SHOULD BE
HOUR) SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO
CONDITIONS.
EXPOSURE.
FACE SHIELD.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING APPROPRIATE FOR
RISK OF EXPOSURE. EYE BATH, WASHING FACILITIES, SAFETY SHOWER
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
SUPPLEMENTARY LOCAL EXHAUST VENTILATION, CLOSED SYSTEMS, OR RESPIRATORY
PROTECTION MAY BE NEEDED IN SPECIAL CIRCUMSTANCES SUCH AS POORLY
VENTILATED SPACES, EVAPORATION FROM LARGE SURFACES, SPRAYING, H
EATING, ETC.
* Product Identification *
Preparer's Name:NOT PROVIDED
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits:NOT PROVIDED
Code:F
Code:F
Ingred Name:SODIUM SULFITE
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:HYDROQUINONE
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NOT PROVIDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POTASSIUM HYDROXIDE
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NOT PROVIDED
Code:F
ACGIH STEL:C2 MG/M3
Ingred Name:POTASSIUM BROMIDE
< Wt:1.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:1-PHENYL-3-PYRAZOLIDINONE
< Wt:1.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF EXPOSURE: INHALATION: MIST
IRRITATING. IN CONTACT WITH STRONG ACIDS OR IF HEATED, SULFITES MAY
LIBERATE SULFUR DIOXIDE GAS. SULFUR DIOXIDE GAS IS IRRITATING TO
THE RESPIRATORY TRACT. SOME ASTHMATICS OR HYPERSENSITIVE
INDIVIDUALS MAY EXPERIENCE DIFFICULT BREATHING. EYES: CAUSES BURNS.
SKIN: CAUSES BURNS. MAY CAUSE ALLERGIC SKIN REACTION. INGESTION:
HARMFUL IF SWALLOWED. MAY CAUSE BURNS OF THE GASTROINTESTINAL
TRACT IF SWALLOWED. SOME ASTHMATICS OR SULFITE-SENSITIVE
INDIVIDUALS MAY EXPERIENCE WHEEZING, CHEST TIGHTNESS, STOMACH
UPSET, HIVES, FAINTNESS, WEAKNESS AND DIARRHEA.
Explanation of Carcinogenicity:CARCINOGENICITY CLASSIFICATION
(COMPONENTS PRESENT AT 0.1% OR MORE): - INTERNATIONAL AGENCY FOR
RESEARCH ON CANCER (IARC): NONE - AMERICAN CONFERENCE OF
GOVERNMENTAL INDUSTRIAL HYGIENISTS (ACGIH): NON E - NATIONAL
TOXICOLOGY PROGRAM (NTP): NONE - OCCUPATIONAL SAFETY AND HEALTH
ADMINISTRATION (OSHA): NONE
Effects of Overexposure:INHALATION: MIST IRRITATING. IN CONTACT WITH
STRONG ACIDS OR IF HEATED, SULFITES MAY LIBERATE SULFUR DIOXIDE
GAS. SULFUR DIOXIDE GAS IS IRRITATING TO THE RESPIRATORY TRACT.
SOME ASTHMATICS OR HYPERSE NSITIVE INDIVIDUALS MAY EXPERIENCE
DIFFICULT BREATHING. EYES: CAUSES BURNS. SKIN: CAUSES BURNS. MAY
CAUSE ALLERGIC SKIN REACTION. INGESTION: HARMFUL IF SWALLOWED. MAY
CAUSE BURNS OF THE GASTROINTESTIN AL TRACT IF SWALLOWED. SOME
ASTHMATICS OR SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE
WHEEZING, CHEST TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS,
WEAKNESS AND DIARRHEA.
Medical Cond Aggravated by Exposure:NOT PROVIDED
* First Aid Measures *
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY. GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES:
MEDICAL ATTEN TION IMMEDIATELY. SKIN: IMMEDIATELY FLUSH WITH PLENTY
CLOTHING AND SHOES. GET MEDICAL ATTENTION IMMEDIATELY. WASH
CONTAMINATED CLOTHING BEF ORE REUSE. DESTROY CONTAMINATED SHOES.
INGESTION: DO NOT INDUCE VOMITING. GIVE VICTIM A GLASS OF WATER.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. CALL A
PHYSICIAN OR POISON CONTROL CENTERIMMEDIATELY.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT MATERIAL,
THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:WEAK ACID
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP AWAY FROM
INCOMPATIBLE SUBSTANCES. USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING.
Other Precautions:DO NOT GET IN EYES, ON SKIN, ON CLOTHING. DO NOT
BREATHE MIST OR VAPOR AT CONCENTRATIONS GREATER THAN THE EXPOSURE
LIMITS. THE ROUTINE USE OF A NONALKALINE (ACID) TYPE OF HAND
WILL HELP MINIMIZE THE POSSIBILITY OF A SKIN REACTION.
* Physical/Chemical Properties *
HCC:B1
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:M.P/F.P Text:NOT PROVIDED
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Density:0.6
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT PROVIDED
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID. ODOR: NOT AVAILABLE
Corrosion Rate:NOT PROVIDED
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:NOT PROVIDED
Hazardous Decomposition Products:SULFUR DIOXIDE
* Toxicological Information*
HYDROQUINONE HAS RESULTED IN THE FORMATION OF BENIGN KIDNEY TUMORS
THOUGHT TO BE SECONDARY TO NEPHROPATHY. HYDROQUINONE-INDUCED
NEPHROPATHY FOLLOWING ORALADMINISTRATION HAS BEEN NOTED IN THE
RATS HAS BEEN REPORTED FOLLOWIN G CHRONIC ORAL ADMINISTRATION OF
HYDROQUINONE, THISB FINDING WAS NOT REPRODUCED IN A SUBSEQUENT
STUDY. THERE WAS NO EVIDENCE OF CARCINOGENICITY IN MALE MICE; SOME
EVIDENCE OF CARCINOGENIC ACTIVITY WAS SHOWN IN FEMALE MICE.
* Ecological Information *
Ecological:IT IS EXPECTED TO HAVE THE FOLLOWING PROPERTIES: A LOW
BIOCHEMICAL OXYGENDEMAND AND LITTLE POTENTIAL TO CAUSE OXYGEN
DEPLETION IN AQUEOUS SYSTEMS, A HIGH POTENTIAL TO AFFECT SOME
AQUATIC ORGANISMS,A HIGH POTENTIAL TO AFFECT SECONDARY WASTE
TREATMENT MICROBIAL METABOLISM, A MODERATE POTENTIAL TO AFFECT THE
GERMINATION AND/OR EARLY GROWTH OF SOME PLANTS, A LOW POTENTIAL TO
PERSIST IN THE ENVI RONMENT, A LOW POTENTIAL TO BIOCONCENTRATE.
AFTER DILUTION WITH A LARGE AMOUNT OF WATER, FOLLOWED BY SECONDARY
WASTE TREATMENT, THIS MATERIAL IS NOT EXPECTED TO CAUSE ADVERSE
ENVIRONMENTAL EFFECTS.
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER.
* MSDS Transport Information *
Transport Information:FOR TRANSPORTATION INFORMATION REGARDING THIS
PRODUCT CALL THE KODAK WORLDWIDE TRANSPORTATION HAZMAT HOT LINE:
MONDAY THROUGH FRIDAY .
* Regulatory Information *
SARA Title III Information:CHEMICAL(S) SUBJECT TO THE REPORTING
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:MATERIAL(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER: NONE - MATERIAL(S) KNOWN TO THE STATE
OF CALIFORNIA TO CAUSE ADVERSE REPRODUCTIVE EFFECTS: NONE
* Other Information *
| 1 | gloves_mandatory |
Control Measures
*
Cage: 0BDY9
*
Contractor Summary
*
Cage: 0BDY9
*
Ingredients
*
EXPLO-PROOF EQUIP. KEEP AWAY FROM HEAT, SPKS &
-----------------------------
RESIDUE (LIQ &/OR VAP) & CAN BE DANGEROUS. DO
-----------------------------
CNTNRS TO HEAT, FLAME, SPKS/OTHER
-----------------------------
-----------------------------
BUNGED & PROMPTLY RETURNED TO DRUM
-----------------------------
MANNER & I/A/W GOVT REGS. FOR WORK ON
-----------------------------
REFERENCES PERTAINING TO CLEANING, REPAIRING,
-----------------------------
-----------------------------
RESPS/HOODS. WEAR APPROP, PROPERLY FITTED NIOSH/
-----------------------------
MONITORING DEMONSTRATES VAP/MIST LEVELS ARE BELOW
-----------------------------
RESPIRATOR USE.
-----------------------------
-----------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
% Wt: 0-6
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL:ANESTHETIC. IRRITATION OF RESPIRATORY TRACT OR ACUTE
NERVOUS SYSTEM DEPRESSION CHARACTERIZED BY HEADACHE, DIZZINESS, STAGGERING
GAIT, CONFUSION, UNCONSCIOUSNESS OR COMA. SKIN/EYE CONTACT:PRIMARY IRRITANT.
REPORTS HAVE ASSOCIATED REPEATED & PROLONGED OCCUPATIONAL OVEREXPOSURE TO
SOLVENTS W/ (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL:RESTORE BRTHG. KEEP WARM & QUIET. NOTIFY MD. EYES:FLUSH
DEFINITIVE MED TREATMENT. SKIN:WASH AFFECTED AREAS W/WATER. REMOV E CONTAM
CLTHG. CONSULT MD. INGEST:CALLMD/POIS CTL CTR IMMED. DRINK 1-2 GLASSES OF
WATER TO DILUTE. TREAT SYMPTOMATICALLY. DO NOT INDUCE VOMITING.
*
Handling and Disposal
*
Spill Release Procedures: REMOVE ALL IGNIT SOURCES. MOP UP SPILL/ADD ABSORB.
USE NON-SPARKING TOOLS. USE ADEQ VENT. MOVE LEAKING CNTNRS TO OUT OF DOORS
OBSERVING PRECS W/REFERENCE TO FIRE, SPARK & FLAME HAZ. RUN OFF TO
WATERWA Y CREATES FIRE HAZS; NOTIFY FIRE & HLTHAUTHS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: RECLAIM MATERIAL INCINERATE, OR USE SANITARY LANDFILL
METHOD OF DISPOSAL I/A/W STATE, LOCAL & FEDERAL REGULATIONS. DO NOT
INCINERATE CLOSED CONTAINERS. SEAL EMPTY DRUMS TIGHTLY.
Handling And Storage Precautions: STORE IN WELL VENTILATED WAREHOUSE. KEEP OUT
OF DIRECT SUNLIGHT/OTHER HEAT SOURCE. KEEP CNTNRS CLSD. NO SMOKING. USE ONLY
W/ADEQ VENT.
Other Precautions: DO NOT TAKE INTERNALLY; HARMFUL/FATAL IF SWALLOWED. CNTNRS
SHOULD BE GROUNDED WHEN POURING. AVOID FREE FALL OF LIQ IN EXCESS OF A FEW
INCHES. CLOSE CNTNR AFTER EACH USE. DO NOT TRANSFER CONTENTS TO BO
TTLES/OTHER UNLABELLED CNTNRS. (SUPDAT)
*
Fire and Explosion Hazard Information
*
Flash Point Method: TCC
Flash Point Text: SEE ING 2
Lower Limits: SEE ING 1
Extinguishing Media: FOAM, "ALCOHOL" FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures: USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP
N). WATER MAY BE INEFT; HOWEVER, USE WATER SPRAY TO COOL FIRE-EXPOS CLSD
CNTNRS TO PVNT EXPLO. AVOID (SUPDAT)
Unusual Fire/Explosion Hazard: TOX GASES ARE EVOLVED WHEN BURNING. KEEP CNTNR
TIGHTLY CLSD. ISOLATE FROM HEAT, ELEC EQUIP, SPKS, OPEN FLAME & AREAS
WHERE STATIC ELEC MAY BE GENERATED.(SUPDAT)
*
*
Respiratory Protection: IN OPEN AREAS USE NIOSH/MSHA APPRVD MECH FILTER RESP TO
REMOVE SOLID AIRBORNE PARTICLES DURING SPRAY APPLICATION. IN RESTRICTED VENT
AREAS USE NIOSH/MSHA APPRVD CHEM-MECH FILTERS DESIGNED TO REMOVE CO MBINATION
OF PARTICULATES & VAP.
Ventilation: USE APPROVED SPRAY BOOTH. PROVIDE GENERAL DILUTION OR LOCAL
EXHAUST VENTILATION IN VOLUME & PATTERN TO KEEP TLV
Other Protective Equipment: PREVENT PROLONGED SKIN CONTACT W/CONTAMINATED
CLOTHING.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: FIRE FIGHT PROC:UNNEC EXPOS TO FUMES. ANY PERS
EXPOS TO SUCH FUMES SHOULD RECEIVE IMMED MED ATTN. EXPLO HAZ:CLSD CNTNRS MAY
EXPLODE WHEN EXPOS TO EXTREME HEAT. WATER MAY BE USED TO COOL CLSD CNTNRS. D
O NOT APPLY TO HOT SURFS. DO NOT STORE/MIX W/STRONG OXIDANTS. OTHER
PREC:AVOID PRLNG CONT W/SKIN & BRTHG OF VAP/
*
Physical/Chemical Properties
*
Vapor Pres: SEE INGS
Vapor Density: HVR/AIR
Evaporation Rate & Reference: SLOWER THAN ETHER
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
*
Reactivity Data
*
Stability Indicator: YES
CONTAINER. EXPOSURE TO HEAT, SPARKS, OPEN FLAME, HOT SURFACES.
Materials To Avoid: OXYGEN & STRONG OXIDANTS.
Hazardous Decomposition Products: CARBON DIOXIDE & CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Cage: 0BDY9
Company Name: LENMAR, INC.
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE:INHAL:ANESTHETIC. IRRITATION OF
RESPIRATORY TRACT OR ACUTE NERVOUS SYSTEM DEPRESSION CHARACTERIZED BY
HEADACHE, DIZZINESS, STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS OR COMA.
SKIN/EY E CONTACT:PRIMARY IRRITANT. CHRONIC:REPORTS HAVE ASSOCIATED REPEATED
& PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS W/PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A NIOSH-APPROVED PARTICULATE FILTER RESPIRATOR
IS RECOMMENDED IF EXCESSIVE DUST IS GENERATED.
Ventilation:LOCAL EXHAUST AND MECHANICAL VENTILATION RECOMMENDED.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING THIS
MATERIAL.
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:ACTIVATED CARBON
Preparer's Name:D.E. KUBELDIS
* Composition/Information on Ingredients *
Ingred Name:GRAPHITE, SYNTHETIC
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
SKIN- THE PRODUCT IS NOT A PRIMARY SKIN IRRITANT. EYES- THE
PHYSICAL NATURE OF THE PRODUCT MAY P RODUCE EYE IRRITATION.
CHRONIC: THE EFFECTS OF LONG-TERM, LOW-LEVEL EXPOSURES TO THIS
PRODUCT HAVE NOT BEEN DETERMINED.
Effects of Overexposure: SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure: SPECIFIED BY MANUFACTURER.
* First Aid Measures *
SKIN- WASH WITH SOAP AND WATER.
* Fire Fighting Measures *
Extinguishing Media:IF INVOLVED IN FIRE, FLOOD WITH PLENTY OF WATER.
Fire Fighting Procedures:
Unusual Fire/Explosion Hazard:CONTACT WITH STRONG OXIDIZERS SUCH AS
OZONE, LIQUID OXYGEN, CHLORINE, PERMANGANATE, ETC. MAY RESULT IN
FIRE.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP UNUSED CARBON AND DISCARD IN REFUSE
CONTAINER OR REPACKAGE.
*Handling and Storage *
Handling and Storage Precautions:WET ACTIVATED CARBON REMOVES OXYGEN
FROM AIR CAUSING A SEVERE HAZARD TO WORKERS INSIDE CARBON VESSELS
AND ENCLOSED OR CONFINED SPACES.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. EXERCISE CAUTION IN
THE STORAGE AND HANDLING OF ALL CHEMICAL SUBSTANCES.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:2.3 G/CC
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK PARTICULATE SOLID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS SUCH AS OZONE, LIQUID OXYGEN, CHLORINE, PERMANGANATE,
ETC.
Stability Condition to Avoid:
Hazardous Decomposition Products:CARBON MONOXIDE MAY BE GENERATED IN
THE EVENT OF FIRE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF UNUSED CARBON IN REFUSE CONTAINER.
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
* First Aid Measures *
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
* Physical/Chemical Properties *
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
* Stability and Reactivity Data *
STRONG OXIDIZERS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:APPROVED AIR SUPPLIED RESPIRATOR ADVISED IN
ABSNECE OF PROPER ENVIRONMENTAL CONTROL.
Ventilation:PROVIDE SUFFICIENT MECHANICAL VENTILATION TO MAINTAIN
EXPOSURE BELOW TLV(S).
Other Protective Equipment:IMPERVIOUS CLOTHING AND BOOTS.
Supplemental Safety and Health
NK
* Product Identification *
Product ID:CHLORINATED HYDROCARBON
Preparer's Name:PAUL LINDQUIST
* Composition/Information on Ingredients *
Ingred Name:PERCHLOROETHYLENE (TETRACHLOROETHYLENE) (SARA III)
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYES-SEVERE
IRRIT,REDNESS,TEARING,BLURRED VISION.SKIN-MOD
IRRIT,DEFATTING,DERMITITS.INHALE-NASAL RESPIRATORY IRRIT,
DIZZINESS,WEAKNESS,FATIGUE,NAUSEA,HEADACHE,POSS INCONS,EVEN
DEATH.INGEST- GASTROINTE STINAL IRRIT,NAUSEA,VOMITING,DIARRHEA.
Effects of Overexposure:HAS BEEN SUGGESTED AS A CAUSE OF THE FOLLOWING
EFFECTS IN HUMANS: LIVER ABNORMALITIES,KIDNEY DAMAGE, SPLEEN
DAMAGE, LUNG DAMAGE, BRAIN DAMAGE.
* First Aid Measures *
First Aid:SKIN-THORO WASH EXPOSED AREA W/SOAP/WATER. REMVE CONTAIM
CLOTH.EYES-FLUSH W/LRG AMTS WATER,LIFT EYELIDS OCCAS.GET MED
ATTN.INGEST-DONT INDUCE VOMIT.IMMED DRI 2 GLASSES WATER.NEVER
GIVE ANYTHING BY M OUTH TO UNCONSC.PERSON.GET MED ATTN.INHALE-GET
FRESH AIR.IF BREATH DIFF,GIVE OXYGEN.IF BREATH STOPPED,GIVE
ARTIFICIAL RESP.KEEP WARM, GET MED ATTN.EPINEPHRINE/EPHEDRINE MAY
ADVERSELY AFFECT HEART,FATA
* Fire Fighting Measures *
Extinguishing Media:WATER FOG
Fire Fighting Procedures:WATER MAY BE USED TO KEEP FIRE-EXPOSED
CONTAINERS COOL UNTIL FIRE IS OUT.WEAR SCBA W/FULL FACE PIECE
OPERATED IN POSITIVE PRESSURE DEMAND MODE.
Unusual Fire/Explosion Hazard:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUM(EVEN EMPTY)BECAUSE PRODUCT(EVEN RESIDUE)CAN IGNITE
EXPLOSIVELY.
* Accidental Release Measures *
Spill Release Procedures:SMALL-ABSORB LIQUID ON PAPER,VERMIQULITE,
FLOOR ABSORB,OTHER ABSORB MATERIAL.TRANSFER TO HOOD.LARGE-CLEAR
AREA.STOP SPILL SOURCE,DIKE AREA,PUMP LIQ SALVAGE TA.REMAIN LIQ
MAY BE TAKEN UP W/ SAND,CLAY ,EARTH,SHOVELED INTO CONTAINERS.
* Physical/Chemical Properties *
HCC:T4
Vapor Density:(AIR=1)5.7
Appearance and Odor:CLEAR LIQUID, SHARP ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL,STATE,
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURE EXCEED THE EXPOSURE LIMITS, WEAR AN
APPROVED DUST/MIST RESPIRATOR/SUPPLIED AIR RESPIRATOR.
Ventilation:GENERAL LABORATORY VENTILATION SHOULD BE ADEQUATE.
Other Protective Equipment:IMPERVIOUS CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
HEALTH HAZARDS CONT'D: PROLONGED/REPEATED EXPOSURE MAY CAUSE
DERMATITIS. CHRONIC EXPOSURE MAY DAMAGE TO THE LIVER & PANCREAS.
* Product Identification *
CAGE:0Z9R8
CAGE:0Z9R8
* Composition/Information on Ingredients *
Ingred Name:FERRIC CHLORIDE
ACGIH TLV:1 MG/CUM
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION TO MUCOUS
MEMBRANES & RESPIRATORY TRACT, LUNG DAMAGE. SKIN: IRRITATION,
CHEMICAL BURNS, SENSITIZATION. EYES: IRRITATION, BURNS. INGESTION:
GI IRRITATION. LARGE AMOUNTS WILL CAUS E MASSIVE IRON ABSORPTION
WHICH CAUSES DAMAGE TO SYSTEMIC BLOOD VESSELS & LIVER. (SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNING, BURNS, BROWN
DISCOLORATION, NAUSEA, VOMITING, DIARRHEA, ABDOMINAL PAIN.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY &/SKIN
DISEASES.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED. SKIN:
INGESTION: NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS/CONVULSING PERSON. IF CONSCIOUS, RINSE MOUTH
W/WATER/MILK. GIVE MILK/WATER TO DILUTE. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING AREAS.
Fire Fighting Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
COLLECT W/ABSORBENT MATERIAL & PLACE IN A CONTAINER FOR DISPOSAL.
*Handling and Storage *
Other Precautions:KEEP OUT OF REACH OF CHILDREN. RINSE IMMEDIATELY
W/PLENTY OF WATER. AVOID BREATHING, TOUCHING, SMOKING & CONTACT
W/SKIN & EYES.
* Physical/Chemical Properties *
Vapor Pres:AS WATER
Vapor Density:AS WATER
pH:4.9
Solubility in Water:COMPLETE
Appearance and Odor:BRIGHT YELLOW LIQUID W/NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALLYL CHLORIDE, AROMATIC MONOMERS, ETHYLENE
OXIDE, CORROSIVE TO METALS.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:HYDROGEN CHLORIDE GAS
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
COLLECTED FOR PROPER DISPOSAL.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPRVD ORGANIC RESP IF VAPOR CONC
EXCEEDS TLV.
Ventilation:SUFFICIENT TO KEEP BELOW TLV.
Supplemental Safety and Health
DRYING,DERMATITIS,FOLLICULITIS. INGEST: LOW TOXICITY.
DEPRESSION,HDCH,DROWSINESS,NAUSEA,VOMITING,DIARRHEA,IRRITATION.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM OIL, REFINED
Ingred Name:ADDITIVES
* Hazards Identification *
Effects of Overexposure:INH: DROWSINESS,DIZZ,HDCH,NAUS,LUNG IRRIT.CHEM
PNEUMONITIS. EYES: IRRITATION. SEE SUP DATA.
* First Aid Measures *
First Aid:INH: REMOVE TO FRESH AIR. RESP SUPPORT IF NECESSARY. SEEK
AID. SKIN: WASH WITH SOAP & WATER(SUBCUTANEOUS INJECTION IS A
MEDICAL EMERGEN CY - SEEK MEDICAL AID IMMED. SEE OTHER PRECAUTIONS
* Fire Fighting Measures *
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM OR WATER FOG
Fire Fighting Procedures:SELF-CONT BREATH APP.
Unusual Fire/Explosion Hazard:WATER MAY CAUSE FROTHING. THERMAL
DECOMPOSITION PRODUCT CO*2, CO.
* Accidental Release Measures *
Spill Release Procedures:FOLLOW ACCEPTED INDUSTRIAL PRACTICES AND/OR
LOCAL, STATE AND FEDERAL REGULATIONS. CHECK BEFORE HANDLING.
*Handling and Storage *
KEEP AWAY FROM IGNITION SOURCES. DOT HAZARD LABEL NOT REQUIRED.
Other Precautions:FIRST AID/ INGEST: DO NOT INDUCE VOMITING, CALL MD.
ASPIRATION MAY CAUSE CHEMICAL PNEUMONITIS OR LIPOID PNEUMONIA.
* Physical/Chemical Properties *
HCC:V6
Vapor Density:>1
Evaporation Rate & Reference:<1(BUAC = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT AMBER LIQUID; SULFURIZED ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS: CO,
CO*2
* Disposal Considerations *
Waste Disposal Methods:WASTE DISPOSAL METHOD MUST BE IAW FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE SUPPLIED-AIR RESPIRATORY PROTECTION IN
CONFINED OR ENCLOSED SPACES IF NEEDED.
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION IS NORMALLY ADEQUATE.
Other Protective Equipment:EYE WASH STATION
Work Hygienic Practices:MINIMIZE BREATHING VAPOR,MIST OR FUMES.REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE.DISCARD OIL-SOAKED
SHOES.
Supplemental Safety and Health
EMPTY CONTAINERS ARE DANGEROUS;DO NOT PRESSURIZE,CUT,WELD,BRAZE,SOLDER
DRILL,GRIND OR EXPOSE TO HEAT,FLAME,SPARKS OR OTHER SOURCES OF
IGNITION;MAY EXPLODE AND CAUSE INJURY.DO NOT CLEAN;DRAIN,BUNG AND
RETURN TO DRUM RECONDITIONER.
* Product Identification *
Preparer's Name:WILLIAM J. MAHONEY
* Composition/Information on Ingredients *
Ingred Name:REFINED HEAVY PARAFFINIC DISTILLATES
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:ZINC DIALKYLDITHIOPHOSPHATE AND/OR ZINC DIARYL
DITHIOPHOSPHATE
Other REC Limits:NONE SPECIFIED
Ingred Name:DISTILLATES, HYDROTREATED HEAVY PARAFFINIC/DETERGENT &
DISPERSANT IN HIGHLY REFINED BASE OIL
Fraction by Wt: 0.6-0.7%
Other REC Limits:NONE SPECIFIED
Ingred Name:CHLORINE AS CHLORO-ORGANO COMPLEX
Other REC Limits:NONE SPECIFIED
Ingred Name:CALCIUM SULFONATE AND/OR CALCIUM PHENATE
Fraction by Wt: 0.4-0.5%
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Explanation of Carcinogenicity:MFG STATES THAT ZINC DIALKYL/DIARYL
DITHIOPHOSPHATE CAUSES TESTICULAR MUTATION WHEN APPLIED TO SKIN OF
LAB ANIMALS.
Effects of Overexposure:DUE TO LOW ORDER OF DERMAL & ORAL TOXICITY, THE
SIGNS & SYMPTOMS OF OVER EXPOSURE ARE UNKNOWN.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES & SKIN MAY BE AT
INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
First Aid:INHALATION:REMOVE TO FRESH AIR.GET MEDICAL ATTENTION, IF
EYELIDS OPEN.GET MEDICAL ATTENTION.SKIN:REMOVE CONTAMINATED
CLOTHING.WASH FIRST WITH WATERLESS SOAP,THEN SOAP AND
WATER.INGESTION:DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL
ATTENTION.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:PHOSGENE GAS CAN BE LIBERATED WHEN
CHLORO-ORGANICS BURN
* Accidental Release Measures *
Spill Release Procedures:DIKE & CONTAIN SPILL WITH INERT MATERIAL
(SAND,EARTH,FULLERS EARTH ETC.).TRANSFER LIQUID TO DRUMS OR OTHER
CONTAINERS FOR RECOVERY OR DISPOSAL.AREA MAY BE SLIPPERY.CARE
SHOULD BE TAKEN TO AVOID FALLS. PREVENT MATERIAL FROM GETTING INTO
SEWERS & WATERS
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:THESE LUBRICANTS BECOME VERY VISCOUS
WHEN STORED AT LOW TEMPERATURE. THEY CONGEAL AT TEMPERATURE FROM
Other Precautions:USE PRODUCT WITH CAUTION AROUND OPEN FLAMES, HEAT,
SPARKS, PILOT LIGHTS & STATIC ELECTRICITY. EMPTY CONTAINER
WARNING:"EMPTY" CONTAINERS RETAIN RESIDUE (LIQUID AND/OR VAPOR) &
CAN BE DANGEROUS.SEE SUP L. DATA SECTION.
* Physical/Chemical Properties *
HCC:V6
Melt/Freeze Pt:M.P/F.P Text:0 (UNITS?)
Vapor Pres:1MM
Vapor Density:1
Spec Gravity:1
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE (0)
Appearance and Odor:LIQUID;DARK RED;ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SULFUR & NITROGEN COMPOUNDS AND PHOSGENE GAS
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF CONTAMINATED DIKING MATERIAL AND
UNRECOVERABLE LIQUID ACCORDING TO CURRENT FEDERAL, STATE AND LOCAL
LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING AND ADMINISTRATIVE CONTROLS OF
AIR CONTAMINANTS ARE NOT POSSIBLE, USE RESPIRATORY DEVICES APPROVED
BY NIOSH/ MSHA FOR PROTECTION AGAINST SPRAY MIST AND VAPORS.
Ventilation:LOCAL EXHAUST PREFERABLE. MECHANICAL (GENERAL) EXHAUST
ACCEPTABLE. SPECIAL VENTILATION REQUIRED TO KEEP BELOW TLV/LEL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING, DISCARD
CONTAMINATED SHOES. WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC: OBTAIN MED ATTN. WATER SPRAY MAY BE INEFFECTIVE. WATER
MAY BE USED TO COOL CLOSED CONTRS TO PREVENT PRESSURE BUILD-UP AND
POSSIBLE AUTO-IGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME H EAT.
* Product Identification *
CAGE:ACEHA
CAGE:ACEHA
* Composition/Information on Ingredients *
FLASH). VP: 0.5.
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS). VP:
2.
Ingred Name:ETHANOL, 2-PROPOXY; (N-PROPOXY ETHANOL). VP:0.6.
Fraction by Wt: <1%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION IS ANESTHETIC.
IRRITATION OF RESPIRATORY TRACT OR NERVOUS SYSTEM DEPRESSION.
HEADACHE, DIZZINESS, NAUSEA, CONFUSION, UNCONSCIOUSNESS OR COMA.
SKIN OR EYE CONTACT: PRIMARY IRRITATION. CHRONIC: REPORTS HAVE
ASSOCIATED RPTD/PRLNG OCCUPATIONAL OVEREXPOSURE TO SOLVENTS W/PERM
BRAIN & NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: REMOVE FROM EXPOSURE, RESTORE BREATHING, KEEP WARM &
QUIET, NOTIFY MD. EYES: FLUSH IMMEDIATELY W/RUNNING WATER FOR A
CREAM. NOTIF Y MD IN ALL CASES. INGEST: CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:0.9%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
DURING EMER CNDTNS OVEREXP TO DECOMP PROD MAY CAUSE HLTH HAZ. SYMP
MAY NOT BE IMMED APPARENT. (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLOSED. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS, & OPEN FLAME. HEAT MAY CAUSE PRESSURE
BUILD-UP IN CLOSED CONTRS, WATER MAY BE USED TO COOL.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DOL STORAGE CATEGORY - 2. CONTENTS ARE
COMBUSTIBLE, KEEP AWAY FROM HEAT & OPEN FLAME. USE ONLY W/ADEQ
VENT. AVOID BRTHG VAPOR & SPRAY MIST.
Other Precautions:AVOID CONT W/SKIN & EYES. WASH HANDS AFTER USING.
KEEP CONTR CLOSED WHEN NOT IN USE. DO NOT TRANSFER CONTENTS TO
OTHER CONTRS FOR STOR. DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN. CONSULT N FPA CODE. USE APPRVD BOND/GROUND PROC.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:HIGH TEMPERATURES, OPEN FLAME.
Hazardous Decomposition Products:BY FIRE: CO2, CO.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE W/FEDERAL,
STATE, AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
BY DGSC-STF.
* Product Identification *
Product ID:OA2WA
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
* Physical/Chemical Properties *
HCC:A3
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A NIOSH/MSHA APPROVED RESPIRATOR IF TLV IS
Ventilation:PROVIDE SUFFICIENT MECHANICAL VENTILATION W/EXPLOSION PROOF
EQUIPMENT TO MAINTAIN EXPOSURE LEVEL BELOW TLV/PEL.
Other Protective Equipment:USE EYE WASH & SAFETY SHOWER. USE IMPERVIOUS
CLOTHING OR CHANGE CONTAMINATED CLOTHING IMMEDIATELY.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:NEARBY CONTR COOL. AVOID SPREADING BURING LIQ W/WATER
USED FOR COOLING PURPOSES. EXPLO HAZ:MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. THERMAL DECOMP PRODS MAY INCL HCL & PHOSGENE. EFTS
OF OVEREXP:COORDINATION & FATIGUE). ASPIR HAZ - THIS MATL CAN ENTER
LUNGS DURING SWALLOWING OR (SEE INGRED 4)
* Product Identification *
Product ID:PROFORMER
CAGE:0C4T4
CAGE:0C4T4
* Composition/Information on Ingredients *
Ingred Name:ING 6:CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USED IN
HUMANS ACUTELY OR CHRONICALLY EXPOSED TO CHLOROCARBONS .
Ingred Name:FIRST AID PROC:& INTO FRESH AIR. IF BRTHG IS DFCLT, O*2
SHOULD BE ADMINSTERED BY QUALIFIED PERS. SEEK MD IMMED. (ING 9)
Ingred Name:ING 8:INGEST:SEEK EMER MED ATTN. THIS MATL IS SLIGHTLY TOX
Ingred Name:ING 9:PLACE ON THE LEFT SIDE W/HEAD DOWN. DO NOT GIVE
VICTIM UNATTENDED.
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
OSHA PEL:SEE TABLE Z3
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
Ozone Depleting Chemical:1
Ingred Name:SUPP DATA:VOM & CAUSE LUNG INFLAMM & DAM. ACUTE:MAY CAUSE
IRRIT, HDCH, NAUS, DIZZ, FATIGUE, LOSS OF COORDINATION (ING 5)
Ingred Name:ING 4:OR UNCON. CHRONIC:NONE RECOGNIZED. CHLOROCARBON
MATERIALS HAVE PRDCED SENSIT OF THE MYOCARDIUM TO (ING 6)
Ingred Name:ING 5:EPINEPHRINE IN LAB ANIMALS & COULD HAVE A SIMILAR EFT
IN HUMANS. ADRENOMIMETICS (E.G. EPINEPHRINE) MAY BE (ING 7)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE:IRRITANT. DIRECT CONT W/THE LIQ OR
EXPOS TO VAP/MIST MAY CAUSE STINGING, TEARING, REDNESS & SWELL.
SKIN:MAY CAUSE IRRIT. PRLNGD/RPTD CONT MAY CAUSE REDNESS, BURNING &
DRYING & CRACKING. MAY BE ABS ORBED THRU THE SKIN. CONT MAY RSLT IN
SKIN ABSORP BUT SYMPS OF TOX ARE NOT ANTIC BY THIS ROUTE (SEE EFTS
OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA. IARC - GROUP 2A
Effects of Overexposure:HLTH HAZ:ALONE UNDER NORM CNDTNS OF USE.
INHAL:BRTHG HIGH CONC OF VAP/MIST MAY CAUSE IRRIT OF THE
NOSE/THROAT. SIGNS OF NERV SYS DEPRESS (E.G. DROW, DIZZ, LOSS OF
COORDINATION & FATIGUE). INGEST:EXCES SIVE QTYS MAY CAUSE IRRIT OF
THE DIGESTIVE TRACT. SIGNS OF NERV SYS DEPERSS (E.G. DROW, DIZZ,
LOSS OF (SEE SUPP DATA)
Medical Cond Aggravated by Exposure:PERSON W/PRE-EXISTING SKIN
DISORDERS & RESPIRATORY SYMPTOMS ASSOC W/PRE-EXISTING LUNG
DISORDERS (E.G. ASTHMA-LIKE CONDITION) MAY BE AGGRAVATED TO
EXPOSURE TO THIS MATERIAL.
* First Aid Measures *
First Aid:EYE:MOVE VICTIM AWAY FROM EXPOS TO VAP & INTO FRESH AIR. IF
IRRIT/REDNESS DEVELOPS, SEEK MD. FOR DIRECT CONT, HOLD EYELIDS
REMOVE CONTA MD CLTHG. CLEANSE THORO BY WASH W/MILD SOAP & WATER.
IF IRRIT OR REDNESS DEVELOPS & PERSISTS, SEEK MD. INHAL:IF
RESP/OTHER SYMPS OF EXPOS DEVELOP, MOVE VICTIM AWAY FROM SOURCE OF
EXPOS (SEE INGRED 8)
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:WATER SPRAY, FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD PRESS DEMAND SCBA &
FULL PROT EQUIP . FULL STREAM WATER MAY BE UNSUITABLE AS EXTING
METH, BUT IS HELPFUL IN KEEPING (SEE SUPP DATA)
Unusual Fire/Explosion Hazard:DO NOT APPLY TO HOT SURF. KEEP AWAY FROM
HEAT, SPARKS & OPEN FLAME. DO NOT STORE/MIX W/STRONG OXIDANTS. KEEP
CONTRS TIGHTLY CLSD. CLSD CONTRS (SEE SUPP DATA)
* Accidental Release Measures *
Spill Release Procedures:PROVIDE ADEQUATE VENTILTION. SOAK UP W/
DIATOMACEOUS SILICA & PICK UP W/SHOVEL. VAPOR IS HEAVIER THAN AIR &
MAY TRAVEL A CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION &
FLASHBACK.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTRS CLSD WHEN NOT IN USE. DO
NOT STORE/HNDL NEAR HEAT, FLAMES, SPARKS & STRONG OXIDANTS. STORE
IN COOL, WELL VENTD AREA. AVOID BRTHG VAPS.
Other Precautions:ROTATE STOCK, USE OLDER MATLS FIRST. INSPECT FOR
LEAKS IN ALL CONTRS. NO SMOKING IN AREA OF USE. DO NOT USE IN THE
GEN VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURF. HEAT &/OR UV
RADIA MAY CAUSE TH E FORMATION OF HCL &/OR PHOSGENE .
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:2.0
Vapor Density:>1
Spec Gravity:1.2
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID; MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID HEAT OR FLAME.
Hazardous Decomposition Products:CO2, CO, HCL, PHOSGENE, &
UNIDENTIFIED ORGANIC COMPOUNDS MAY BE FORMED DURING COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF ALL WASTE IN ACCORDANCE W/FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AVOID BREATHING VAPO OF HEATED PRODUCT. DO NOT
ENTER TANKS WITHOUT BREATHING EQPMT.IF TLV IS EXCEEDED USE APPROVED
ORGANIC VAPOR RESPIRATOR.
Ventilation:LOCAL EXHAUST RECOMMENDED NEAR HEATED PRODUCT.
Other Protective Equipment:RUBBER APRON,SHOES.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING IMMED & WASH
BEFORE REUSE.
Supplemental Safety and Health
HEALTH HAZ:GLYCOL MAY BE EMBRYOTOXIC & TERATOGENIC BY ORAL/INHAL RTS.
DISPO:RECOMMENDED CRUSHING TO PREVENT UNAUTHORIZED REUSE.
* Product Identification *
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONG VAP/MIST BREATH CAUSE RESP
IRRIT,UNCONSC.SWALLOWING WIL CAUSE ACUTE POISONING RESULTING IN
SEVERE ABDOMINAL DISTURBANCES,CNS DEPRESS,RESP &/OR RENAL
FAILURE.EYE:TEMP IRRIT,VAP IRRIT.PROL SKINCONTACT DEHYDRATING
EFFECT RESULTING INTEMP IRRIT.VAP LITTLE/NO EFFECT ON SKIN.ANIMAL
STUDIES INDICATE ETHYLENE (SUPPL)
Effects of Overexposure:UNCONSCIOUSNESS, RESP IRRIT, ACUTE POISONING
RESULTING IN SEVERE ABDONIMAL DISTURBANCES, CNS DEPRESS, RESP &/OR
RENAL FAILURE. TEMP EYE IRRIT, DEHYDRATING SKIN EFFECT RESULTING IN
TEMP IRRIT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
ATTN.SKIN:WASH AREAS W/SOAP/WATER.IRRIT DEVELOPS CONSULT
PHYSICIAN.INGEST:INDUCE VOMIT.NEVER GIVE FLUIDS OR INDUCE VOMIT IF
VICTIM IS UNCONSC OR HAV ING CONVULSIONS.GET IMMED MED
ATTN.INHAL:MOVE TO FRESH AIR.AID BREATHING IF NECESSARY & GET MED
ATTN.
* Fire Fighting Measures *
Flash Point Method:COC
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:USE WATER FOG, ALCOHOL FOAM, CO2 OR DRY CHEMICAL
EXTINGUISHING MEDIA.
Fire Fighting Procedures:FIREFIGHTERS SHOULD BE EQUIPPED
W/SELF-CONTAINED BREATHING APPARATUS & TURNOUT GEAR.AVOID BREATHING
VAPORS OR FUMES OF HEATED OR BURNING PRODUCT.
Unusual Fire/Explosion Hazard:VAPORS FROM HEATED (>FLASH POINT) PRODUCT
MAY TRAVEL TO A SOURCE OF IGNITION & FLASHBACK.
* Accidental Release Measures *
Spill Release Procedures:NOT REGULATED PRODUCT.CLEAN UP QUICKLY AS
SPILLS CONSTITUTE SLIPPING HAZ.ABSORB ON ABSORBENT MATL OR DIKE &
PUMP INTO DRUMS.CLEAN UP W/COOL WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:T6
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Density:NP
Viscosity:NP
Evaporation Rate & Reference:NP
Solubility in Water:INFINITE.
Appearance and Odor:CLEAR, GREEN DYED LIQUID, GLYCOL ODOR.,
INTENSITY:FAINT.
Percent Volatiles by Volume:NP
Corrosion Rate:NP
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:INCINERATE OR BURY @LICENSED FACILITY.DO NOT
DISCAHRGE INTO WATERWAYS.DISCHARGE TO SEWER SYSTEMS W/ADEQUTE
TREATMENT & PRIOR TO APPROVALS ACCEPTABLE.DR:RECOMMEND PRODUCT
LABELS BE PRESERVED ON DR TIL CLEANED/RENOVATED IN LIC FACILITY.GL
JUGS:(SUPPLE)
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:UNDER NORMAL MAUNFACTURING CONDITIONS, NO
RESPIRATORY PROTECTION IS REQUIRED WHEN USING THIS PRODUCT.
SELF-CONTAINED BRATHING APPARATUS IS REQUIRED IF A LARGE RELEASE
OCCURS.
Ventilation:"SEE SUPPLEMENTAL SAFETY AND HEALTH"
LIQUID.
LIQUID.
Supplemental Safety and Health
NORMAL VENTILATION FOR STANDARD MANUFACTURING PROCEDURES IF GENERALLY
ADEQUATE. LOCAL EXHAUST USED IF LARGE AMOUNTS ARE RELEASED.
VENTILATION CONTINUED: MECHANICAL VENTILATION SHOULD BE USED IN LOW
ORENCLOSED PLACES.
* Product Identification *
* Composition/Information on Ingredients *
Ozone Depleting Chemical:1
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION OF HIGH CONCENTRATIONS OF
VAPORS IS HARMFUL AND MAY CAUSE HEART IRREGULARITIES,
UNCONSCIOUSNESS, OR DEATH. INTENTIONAL MISUSE OR DELIBERATE
INHALTION MAY CAUSE DEATH WITHOUT WARNING. VAPOR REDUCES OXYGEN
AVAILABLE FOR BREATHING AND IS HEAVIER THAN AIR. LIQUID CONTACT CAN
CAUSE FROSTBITE. MAY CAUSE EYE IRRITATION.
Explanation of Carcinogenicity:NONE OF THE COMPONENTS PRESENT IN THIS
MATERIAL AT CONCENTRATIONS EQUAL TO OR GREATER THAN 0.1% ARE LISTED
BY IARC, NTP, OSHA OR ACGIH AS A CARCINOGEN.
Effects of Overexposure:HUMAN HEALTH EFFECTS OF OVEREXPOSURE BY EYE
CONTACT WITH THE VAPOR MAY INCLUDE EYE IRRITATION WITH DISCOMFORT,
TEARING, OR BLURRING OF VISION. SKIN CONTACT WITH THE LIQUID MAY
CAUSE FROSTBITE. INHALAT ION OF THE VAPORS MAY CAUSE TEMPORARY
NERVOUS SYSTEM DEPRESSION WITH ANESTHETIC EFFECTS SUCH AS
DIZZINESS, HEADACHE, CONFUSION, INCOORDINATION, AND LOSS OF
CONSCIOUSNESS; TEMPORARY ALTERATION OF HEART 'S ELECTRICAL ACTIVITY
WITH IRREGULAR PULSE, PALPITATIONS, OR INADEQUATE CIRCULATION, OR
THE EFFECTS OF EXCLUSION OF OXYGEN WITH GROSSLY EXCESSIVE EXPOSURE.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PREEXISTING
DISEASES OF CENTRAL NERVOUS OR CARDIOVASCULAR SYSTEM MAY HAVE
INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURE.
* First Aid Measures *
First Aid:INHALATION: IF HIGH CONCENTRATIONS ARE INHALED, IMMEDIATELY
REMOVE TO FRESH AIR. KEEP PERSON CALM. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
CALL PHYSICIAN . SKIN: FLUSH SKIN WITH WATER. TREAT FOR FROSTBITE
IF NECESSARY BY GENTLY WARMING AFFECTED AREA. EYE: IMMEDIATELY
PHYSICIAN. INGESTION: IN GESTION IS NOT CONSIDERED A POTENTIAL
ROUTE OF EXPOSURE. NOTE: BECAUSE OF POSSIBLE DISTURBANCE OF CARDIAC
RHYTHM, CATECHOLAMINE DRUGS, SUCH AS EPINEPHRINE, SHOULD ONLY BE
USED WITH SPECIAL CAUTION IN SITUATIONS OF EMERGENCY LIFE SUPPORT.
* Fire Fighting Measures *
Flash Point:WILL NOT BURN
Extinguishing Media:AS APPROPRIATE FOR COMBUSTIBLES IN AREA.
Fire Fighting Procedures:USE WATER SPRAY OR FOG TO COOL CONTAINERS.
SELF-CONTAINED BREATHING APPARATUS IS REQUIRED IF CYLINDERS RUPTURE
AND CONTENTS ARE RELEASED UNDER FIRE CONDITIONS.
Unusual Fire/Explosion Hazard:CYLINDERS MAY RUPTURE UNDER FIRE
CONDITIONS. DECOMPOSITION MAY OCCUR.
* Accidental Release Measures *
Spill Release Procedures:SAFEGUARDS (PERSONNEL). NOTE: REVIEW FIRE
FIGHTING MEASURES & HANDLING (PERSONNEL) SECTIONS EFORE PROCEEDING
WITH CLEAN-UP. USE APPROPIATE PERSONAL PROTECTIVE EQUIPMENT DURING
CLEAN-UP. VENTILATE AREA , ESPECIALLY LOW OR ENCLOSED PLACES WHERE
HEAVY VAPORS MIGHT COLLECT. REMOVE OPEN FLAMES. USE SELF-CONTAINED
BREATHING APPARATUS(SCBA) FOR LARGE SPILLS.
*Handling and Storage *
Handling and Storage Precautions:HANDLING (PERSONNEL): USE WITH
SUFFICIENT VENTILATION TO KEEP EMPLOYEES EXPOSURE BELOW RECOMMENDED
DEG F).
Other Precautions:NFPA, NPCA-HMIS. NPCA-HMIS RATING: HEALTH-1,
FLAMMABILITY-0, REACTIVITY-1. PERSONAL PROTECTION RATING TO BE
SUPPLIED BY USER DEPENDING ON USE CONDITIONS.
* Physical/Chemical Properties *
HCC:G3
pH:NEUTRAL
Appearance and Odor:CLEAR, COLORLESS, LIQUIFIED GAS; SLIGHT ETHEREAL
ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH ALKALI OR ALKALINE EARTH-METALS-POWDERED AL, ZN, BE,
ETC.
Stability Condition to Avoid:MATERIAL IS STABLE. HOWEVER, AVOID OPEN
FLAMES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:DECOMPOSITION PRODUCTS ARE HAZARDOUS.
HYDROCHLORIC AND HYDROFLUORIC ACIDS, AND POSSIBLY CARBONYL HALIDES.
* Toxicological Information*
SINGLE HIGH BY INHALATION INCLUDE ANETHESIA & IRREGULAR HEARTBEAT
(CARDIAC ARRTHMIAS). REPEATED INHALATION EXPOSURES PRODUCE ALTERED
RESPIRATORY FUNCTION. LONG-TERM STUDIES HAVE SHOWED NO SIGNIFICANT
CLINICAL, BLOOD CHEMISTRY OR PATHOLOGICAL EFFECTS FOLLOWING
REPEATED EXPOSURES. THE EF FECTS IN ANIMALS FROM LONG-TERM
INGESTION OF THIS MATERIAL INCLUDE SLIGHT ALTERATIONS IN BLOOD
CHEMISTRY & BODY WEIGHT GAIN. NO OTHER CLINICAL, BIOCHEMICAL OR
PATHOLOGICAL SIGSN OF TOXICITY HAVE BEEN OBSERVED. "SEE OTHER
INFORMATION"
* Ecological Information *
MG/L.
* Disposal Considerations *
Waste Disposal Methods:COMPLY WITH FEDERAL, STATE AND LOCAL
REGULATIONS. RECLAIM BY DISTILLATION OR REMOVE TO A PERMITTED WASTE
FACILITY.
* MSDS Transport Information *
Transport Information:SHIPPING INFORMATION: DOT/IMO: PROPER SHIPPING
DOT/IMO LABLE: NONFLAMMABLE GAS. SHIPPING CONTAINERS: TANK CARS,
* Regulatory Information *
SARA Title III Information:TITLE III HAZARD CLASSIFICATION SECTIONS
PRESSURE-YES. HAZARDOUS CHEMICAL LISTS: SARA EXTREMELY HAZARDOUS
SUBSTANCE-NO. CERCLA HAZARDOUS SUBSTA NCE-YES. SARA TOXIC
CHEMICAL-DISCLOSURE AS A TOXIC CHEMICAL IS REQUIRED UNDER SECTION
Federal Regulatory Information:TSCA INVENTORY STATUS:
REPORTED/INCLUDED.
* Other Information *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:HAVE EYE BATH & SAFETY SHOWER NEARBY DURING
USE.
Work Hygienic Practices:WASH W/ SOAP,WATER BEFORE
EATING,DRINKING,SMKNG,USING TOILET FACILITIES.REMOVE CONTAM CLTHG
IMMED,LAUNDER BEFORE REUSE.
Supplemental Safety and Health
HNDLG/STOR PREC:OTHER IGNIT SOURCES.CLOSE CONTR AFTER EACH USE.STORE
ONLY IN ORIGINAL CONTR.OTHER PREC:EYE
WATERING,HEADACHES,DIZZINESS;INCR FRESH AIR,LEAVE AREA.DO NOT TAKE
INTERNALLY.ROUTES OF ENTRY :INGESTION .
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:STODDARD SOLVENT
Other REC Limits:N/K
Ingred Name:VEHICLE
Fraction by Wt: 9.0%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ADDITIVES
Fraction by Wt: 1.0%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIGMENTS
Fraction by Wt: 9.0%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAN CAUSE DEFATTING AND DRYING OF THE
SKIN WHICH MAY RESULT IN DERMATITIS.INHALATION CAN CAUSE
ASPHYXIATION.ASPIRATION OF MATERIAL INTO LUNGS DUE TO VOMITING CAN
CAUSE CHEMICAL PNEUMONITIS WHICH CAN B E FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:SEVERE IRRITATION,REDNESS,TEARING,BLURRED
VISION.SKIN:DEFATTING AND DRYING MAY RESULT IN IRRITATION AND
DERMATITIS.INGESTION:GASTROINTESTINAL
IRRITATION,NAUSEA,VOMITING,DIARRHEA.INHALATION:NASAL & RESPIRATORY
IRRITATION,DIZZINESS,FATIGUE,NAUSEA,HEADACHE,NERVOUS
IRRITABILITY,UNCONSCIOUSNESS,ASPHYXIATION.
Medical Cond Aggravated by Exposure:N/K
* First Aid Measures *
First Aid:EYES:REMOVE CONTACT LENSES IF PRESENT;FLUSH W/ PLENTY OF
THOROUGHLY W/ SOAP & PLENTY OF WATER.IF IRRITATION PERSISTS GET
MEDICAL ATTENTI ON.INGEST:DO NOT INDUCE VOMITING.CALL MD
IMMEDIATELY.KEEP PATIENT WARM & QUIET.ASPIR INTO LUNGS DUE TO VOMIT
CAN CAUSE FATAL CHEM PNEUM.INHAL:REMOVE TO FRESH AIR.MAINTAIN
RESPIRATION AS NEC & CALL MD.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:6.0
Upper Limits:0.9
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,ALCOHOL FOAM AND WATER
FOG.WATER NOT NORMALLY AN EFFECTIVE EXTINGUISHING AGENT.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROT EQUIP
W/ FULL FACEPIECE IN PRESS DEMAND MODE.TOXIC BY-PRODUCTS GIVEN OFF
(CO);AVOID BREATHING SMOKE AND GASES.
Unusual Fire/Explosion Hazard:NONE.HAZARDOUS DECOMPOSITION
PRODUCTS:INCOMPLETE COMBUSTION PRODUCES CARBON MONOXIDE,CARBON
* Accidental Release Measures *
Spill Release Procedures:PROVIDE ADEQUATE VENTILATION.REMOVE IGNITION
SOURCES FROM SPILL AREA.UTILIZE SAND,RAGS,PAPER,VERMICULITE,FLOOR
ABSORBENT MATERIAL & PLACE IN LEAK-PROOF DRUMS FOR DISPOSAL.USE
PROTECTIVE EQUIPMENT.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:KEEP OUT OF SURFACE WATERS & ANY WATER
COURSES OR SEWERS ENTERING/LEADING TO SURFACE WATERS.DO NOT
USE/STORE NEAR HEAT,SPARKS,OPEN FLAMES,(SEE SUPP)
Other Precautions:KEEP OUT OF REACH OF CHILDREN.AVOID SPONT COMBUST OF
CONTAM RAGS,OTHER IGNITABLE MATL BY IMMED WATER IMMERSION.EMPTY
CONTR RETAINS RESIDUES;DO NOT CUT,PUNCTURE,WELD ON/NEAR CONTR.AVOID
INHAL,USE W/ AD EQ VENT.IF EMPLOYEE EXPERIENCES (SUP DA)
* Physical/Chemical Properties *
Decomp Temp:Decomp Text:N/K
Vapor Density:4.8,AIR=1
Solubility in Water:NIL
Appearance and Odor:BRIGHT RED LIQUID;MILD HYDROCARBON ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:INCOMPLETE COMBUSTION PRODUCES CARBON
MONOXIDE,CARBON DIOXIDE,AND UNIDENTIFIED ORGANIC COMPOUNDS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .INCINERATION IS PREFERRED.RCRA
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN DUSTY ENVIRONMENTS, THE USE OF AN OSHA,
NIOSH/MSHA APPROVED RESPIRATOR IS RECOMMENDED.
Ventilation:LOCAL EXHAUST CAN BE USED, IF NECESSARY, TO CONTROL
AIRBORNE DUST LEVELS.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . THE USE OF BARRIER CREAMS OR IMPERVIOUS (SUP
DAT)
Work Hygienic Practices:FOLLOWING WORK WITH PORTLAND CEMENT, WORKERS
SHOULD SHOWER WITH SOAP AND WATER.
Supplemental Safety and Health
OTHER PROT EQUIP: BOOTS AND CLOTHING TO PROTECT THE SKIN FROM CONTACT
WITH WET PORTLAND CEMENT IS RECOMMENDED.
* Product Identification *
Product ID:TYPE II-PC
CAGE:RMCLO
CAGE:RMCLO
* Composition/Information on Ingredients *
Ingred Name:TRICALCIUM SILICATE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DICALCIUM SILICATE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TRICALCIUM ALUMINATE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TETRACALCIUM ALUMINOFERRATE; (TETRA CALCIUM ALUMINO
FERRITE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:GYPSUM
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: WET PORTLAND CEMENT, ESPECIALLY
AS AN ING TO PLASTIC (UNHARDENED) CONCRETE, MORTAR/SLURRIES, CAN
DRY SKIN & CAUSE ALKALI BURNS. CAN IRRITATE EYES & UPPER RESP SYS.
CHRONIC: DUST CAN CAUSE INFLA MM OF LINING TISS OF INTERIOR OF NOSE
&INFLAMM OF CORNEA. PERS WHO ARE ALLERGIC TO CHROMIUM MAY DEVELOP
ALLERGIC DERM.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYES: IRRIGATE (FLOOD) IMMEDIATELY AND REPEATEDLY WITH CLEAN
AND WATER. APPLY STERILE DRESSINGS. GET PROMPT MEDICAL ATTENTION.
INHALAT ION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE OXYGEN OR
ARTIFICIAL RESPIRATION) . INGESTION: CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PORTLAND CEMENT IS NON-COMBUSTIBLE AND
NOT EXPLOSIVE.
* Accidental Release Measures *
Spill Release Procedures:IF SPILLED, IT CAN BE CLEANED UP USING DRY
METHODS THAT DO NOT DISPERSE DUST INTO THE AIR. AVOID BREATHING THE
DUST. EMERGENCY PROCEDURES ARE NOT REQUIRED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:THIS PRODUCT CONTAINS CHEMICAL KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER OR BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM.
* Physical/Chemical Properties *
Solubility in Water:SLIGHT (0.1-1.0%)
Appearance and Odor:GRAY COLORED POWDER, WITH NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:KEEP PORTLAND CEMENT DRY UNTIL USED, TO
PRESERVE PRODUCT UTILITY.
Hazardous Decomposition Products:NONE.
* Disposal Considerations *
Waste Disposal Methods:CAN BE TREATED AS A COMMON WASTE FOR DISPOSAL OR
RETURNED TO THE CONTAINER FOR LATER USE IF IT IS NOT CONTAMINATED
OR WET. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS .
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
* Product Identification *
Preparer's Name:DOD HMIS/DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
OSHA PEL:0.2 FIBERS/CC
Ingred Name:ASBESTOS & POLYTETRAFLUOROETHYLENE COMPOSITION
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
*Handling and Storage *
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
* Physical/Chemical Properties *
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT. TYPICALLY,
Other Protective Equipment:EYE WASH STATION, QUICK DRENCH SHOWER AND
IMPERVIOUS CLOTHING
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
EXPECTED TO HAVE THE FOLLOWING PROPERTIES: A MODERATE BIOCHEMICAL
OXYGEN DEMAND, A MODERATE POTENTIAL TO AFFECT AQUATIC ORGANISMS .
AFTER DILUTION WITH WATER, THIS MATERIAL IS NOT EXPECTED TO CAUSE
ADVERSE EFFECTS.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:WATER
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM THIOSULFATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM ACETATE
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ACETIC ACID (SARA III)
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM METABISULFITE
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES. ACUTE-
INHALATION:EXPECTED TO BE A LOW HAZARD FOR RECOMMENDED HANDLING.
EYES:MAY CAUSE TRANSIENT IRRITATION. SKIN:LOW HAZARD FOR
RECOMMENDED HANDLING. INGESTION:EXPECTED TO BE A LO W INGESTION
HAZARD. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES IRRITATION
* First Aid Measures *
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES:FLUSH WITH
CLOTHING. WASH SKIN WITH SOAP AND PLENTY OF WATER.
INHALATION:REMOVE TO FRE SH AIR. INGESTION:DRINK 1-2 GLASSES OF
WATER. SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. FIRE MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCT.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNT OF WATER.
Neutralizing Agent:NOT RELEVENT
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE AWAY FROM
INCOMPATIBLE MATERIALS.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. AVOID CONTACT WITH
EYES. KEEP OUT OF REACH OF CHILDREN. USE WITH ADEQUATE VENTILATION.
* Physical/Chemical Properties *
HCC:C3
NRC/State Lic Num:NOT RELEVANT
Vapor Density:O.6
pH:4.5
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, VINEGAR ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASES, SODIUM HYPOCHLORITE (BLEACH), STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:AMMONIA, CHORAMINE, NITROGEN OXIDES
(NOX), SULFUR DIOXIDE
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE AMOUNT
OF WATER.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED
Ventilation:GENERAL/LOCAL EXHAUST TO MEET TLV REQUIREMENTS
Other Protective Equipment:ADEQUATE LABORATORY ATTIRE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: FORMS HIGHLY SENSITIVE EXPLOSIVE COMPOUNDS W/HEAVY
DECOMPOSES EXOTHERMICALLY, BURNING W/A VERY HOT FLAME & PRODUCING N
ITROGEN & MOLTEN SODIUM.
* Product Identification *
Preparer's Name:S HEALY
* Composition/Information on Ingredients *
Other REC Limits:0.1 PPM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL IRRITATION. SKIN:
IRRITATION, ABSORPTION, ALLERGIC REACTION. EYES: IRRITATIONS,
CONJUNCTIVITIS. INGESTION: BRONCHIAL IRRITATION, RESPIRATORY
IRRITATION, RESPIRATORY FAILURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, FAINTNESS,
NAUSEA, LOW BLOOD PRESSURE, BLURRED VISION, SHORTNESS OF BREATH,
COLLAPSE, BRONCHITIS, PALPITATION, WEAKNESS & UNSTEADINESS, COMA,
CONVULSIONS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE CPR.
IF BREATHING IS DIFFICULT GIVE OXYGEN. SKIN: WASH OFF THOROUGHLY
TO DRIN K. INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICALS SUCH AS AN SODIUM CARBONATE/SAND.
Fire Fighting Procedures:BURNING SODIUM AZIDE WILL EXPLODE IF WATER IS
USED AS AN EXTINGUISHING MEDIA. SCBA MUST BE WORN.
Unusual Fire/Explosion Hazard:MAY EXPLODE & RELEASE TOXIC FUMES UPON
HEATING. DON'T ALLOW TO CONTACT METALS AT HIGH TEMPS.
(SUPP)
* Accidental Release Measures *
Spill Release Procedures:DILUTE W/RUNNING WATER BEFORE DISCHARGE.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM METALS & ACIDS.
* Physical/Chemical Properties *
Appearance and Odor:WHITE-COLORLESS CRYSTALS/POWDER, ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
METALS, ACIDS, ACID CHLORIDES & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:NITROGEN OXIDES, HYDRAZOIC ACID
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:GOOD VENTILATION IS NEEDED HOWEVER USE NIOSH
APPRVD SCBA FOR PAINTS.
Ventilation:USE ADEQUATE VENTILATION USING EXHAUST FAN.
Other Protective Equipment:AS REQD TO PREVENT PROLONGED OR REPEATED
CONTACT.
Supplemental Safety and Health
TWO PART KIT. THIS IS CATALYST. SEE P/N IND "A" FOR BASE; ALSO SEE
P/N IND "B" FOR OTHER HAZ INGREDIENTS; MIL SPEC REFEENCE:
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:N-BUTYL ALCOHOL (SARA III)
* Hazards Identification *
Effects of Overexposure:EYES:MODERATE IRRIT;SKIN:POSSIBLE IRRIT BY
SOLVENTS;INH:SOLVENT VAPORS CAN CAUSE IRRIT OR NARCOSIS
* First Aid Measures *
First Aid:SKIN:WIPE OFF WITH A RAG THEN THOROUGH RINSING W/H*2O &
MIN & CONSULT AN EYE PHYSICIAN;INH:REMOVE TO FRESH AIR.GIVE
CPR/OXYGEN IF NEEDE D.
* Fire Fighting Measures *
Lower Limits:1.7
Extinguishing Media:CO*2,DRY CHEM,FOAM
Fire Fighting Procedures:DO NOT USE H*2O STREAM ON FIRE.H*2O SPRAY/FOG
IS MORE EFFCTV
Unusual Fire/Explosion Hazard:CAUTION AGAINST APPLICATION TO HOT
SURFACES & USE IN AREAS WHERE SOURCES OF IGNITION MAY BE PRESENT.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS.ELIM IGN
SOURCES.USE SAFETY EQUIP.VENTLATE AREA.STOP LEAK W/O RISK.ABSORB SM
SPILL W/OIL ABSORBNG COMPD/RAGS;DIKE LG SPILL.PUMP LIQ TO SALVAGE
TANK.SHOVEL UP RESIDUE INTO COVRD DRUMS;PER MFR,FLUSH AREA W/LG
AMOH*2O.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY WELL VENTILATED,LOW
FIRE RISK AREA.KEEP CONTNRS TIGHTLY CLOSED.KEEP AWAY FM HEAT,SPARK
OR OPEN FLAME.
Other Precautions:AVOID PROLONGED INHALATION OF VAP.PER MFR,WATER SPRAY
OR FOG CAN BE USED EFFECTIVELY ON FIRE AND TO COOL HEAT/FIRE
EXPOSED CONTNRS.
* Physical/Chemical Properties *
HCC:F2
Vapor Density:>1.0
Evaporation Rate & Reference:<1(SLWR THAN ETHR)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR THIN LIQUID,ODOR OF MEK
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING & CORROSIVE MATERIALS.
Stability Condition to Avoid:SOURCE OF IGN,SPARK,HEAT & OPEN FLAME
* Disposal Considerations *
Waste Disposal Methods:KEEP IN CLOSED CONTNRS PENDING DISPOSAL.MFR
SUGGESTED,DISPOSE IN TIGHTLY CLOSED CONTAINERS & FINALLY DISPOSE BY
SANITARY LANDFILL IAW APPLICABLE REGS;HANDLE & DISPOSE IN FULL
COMPLIANCE W/ALL FED,STAT E,& LOCAL REGULATIONS CONCERNING WASTE
DISPOSAL
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:SUFFICIENT TO MAINTAIN OPERATOR EXPOSURE <APPLICABLE
OCCUPATIONAL EXPOSURE STANDARDS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
USE OF A HAZARDOUS CHEMICAL MAY REQUIRE SUPPLEMENTAL VENTILATION FOR
PROTECTION OF PERSONNEL & FOR CONTROLLING FIRE/EXPLOSION HAZARD. A
QUALIFIED INDEPENDENT TESTING COMPANY CAN DETERMINE IF EXISTING
CONCENTRATIONS ARE W/IN ESTABLISHED RECOMMENDED/PERMISSIBLE
EXPOSURE LEVELS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:DIETHYLENE GLYCOL BUTYL ETHER ACETATE, ETHANOL, 2-
(2-BUTOXYETHOXY), BUTYL CARBITOL ACETATE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATE IRRITATION. SKIN:
SLIGHT IRRITATION. INHALATION: NASAL & RESPIRATORY IRRITATION, CNS
EFFECTS, DEATH. INGESTION: GI IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, UNCONSCIOUSNESS, VOMITING, DIARRHEA, REDNESS,
TEARING.
* First Aid Measures *
INHALATION: REMOVE TO FRESH AIR. INGESTION: IF CONSCIOUS GIVE 2
GLASSES OF WATER & INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, CO2, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPORS ARE >AIR & MAY TRAVEL ALONG GROUND
TO DISTANT IGNITION SOURCE.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. ABSORB MATERIAL
W/VERMICULITE/FLOOR ABSORBENT. DISPOSE OF CONTAMINATED MATERIALS
*Handling and Storage *
Handling and Storage Precautions:FOR FLAMMABLE/COMBUSTIBLE PRODUCTS,
COMBUSTIBLE LIQUIDS CODE.
Other Precautions:CONTAINERS MAY BE HAZARDOUS WHEN EMPTIED, SINCE
EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES WHICH CAN GENERATE
VAPORS W/IN FLAMMABLE LIMITS.
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PHLOX LIQUID/SEMI-SOLID INK W/MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES/MINERAL ACIDS.
Stability Condition to Avoid:HEAT, FLAME & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO & CO2.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. IT'S THE RESPONSIBILITY OF THE GENERATOR OF THE WASTE
TO DETERMINE WHETHER THE WASTE GENERATED MEETS THE FEDERAL/STATE
HAZARDOUS WASTE CRITERIA.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE GENERALLY REQUIRED. NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:MAINTAIN TLV.
Other Protective Equipment:EYEWASH AND SAFETY SHOWER. RUBBER BOOTS AND
APRON.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ETHANOL, 2-BUTYOXY-;(2-BUTOXYETHANOL)
Fraction by Wt: 3-5%
Ingred Name:SODIUM HYDROXIDE
Fraction by Wt: 1-2%
OSHA PEL:2 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LAB TEST INDICATE POSSIBLE TERATOGIC
POTENTIAL UPON HIGH DOSAGES. MAY CAUSE DAMAGE TO RED BLOOD CELLS
WITH HIGH EXPOSURE. IRRITATES SKIN AND EYES ON CONTACT. INHALATION
MAY CAUSE NAUSEA, DIZZINESS, IR REGULAR PULMONARY RATE, IRREGULAR
BREATHING AND UNCONSCIOUSNESS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:ANIMAL STUDIES CLEARLY DEMONSTRATE DOSE-
RELATED ADVERSE EFFECTS ON CNS, THE HEMATOPOIETIC TISSUES, THE
BLOOD, THE KIDNEYS & LIVER, ASSOCIATED WITH ADMINISTRATION OF
ETHYLENE GLYCOL MONOBUTYL ETHER (E GBE) AND ETHYLENE GLYCOL
MONOBUTYL ETHER ACETATE (EGBEA). (EXTRACTED FROM DHHS (NIOSH)
Medical Cond Aggravated by Exposure:
* First Aid Measures *
HOLDING LIDS APART. SKIN:WASH THOROUGHLY WITH SOAP & WATER. DISCARD
CONTAMINATED CLOTHING. GET MD.INHAL:REMOVE TO FRESH AIR. GIVE
OXYGEN I F NECESSARY. DISCARD CONTAMINATED CLOTHING. GET MD. INHAL:
REMOVE TO FRESH AIR. GIVE OXYGEN. IF NECESSARY, GET MD. INGEST:DO
NOT INDUCE VOMITING. GET MD IMMEDIATELY.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:CO2, WATER, FOAM.
Fire Fighting Procedures:APPROPRIATE METHOD FOR FIRE SOURCES. WEAR
NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE AVAILABLE.
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER. BIODEGRADABLE. ALWAYS CHECK
WITH AUTHORITIES BEFORE RELEASING ANY SUBSTANCES.
Neutralizing Agent:
*Handling and Storage *
HANDLING MATERIALS.
Other Precautions:MOVE WITH BUNGS IN PLACE.
* Physical/Chemical Properties *
HCC:C2
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR BLUE LIQUID WITH A MILD ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:MAY YIELD COX.
* Disposal Considerations *
Waste Disposal Methods:FLUSH TO SEWER. BIODEGRADABLE. DISPOSAL MUST BE
IN ACCORDANCE WITH ALL LOCAL, STATE, AND FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
------------------------------
% Wt: <5.4
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
% Wt: <2.5
OSHA PEL: N/K (FP N)
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
% Wt: <9.0
ACGIH TLV: 2 MG/M3 TDUST
------------------------------
------------------------------
% Wt: <9.0
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: SEE TABLE Z-3
ACGIH TLV: 0.1 MG/M3 RDUST
------------------------------
FOLLOWED BY DFCLTY IN BRTHG & HEART FAILURE,
-----------------------------
-----------------------------
IS CONSIDERED HAZARD BY INHAL. IARC HAS
-----------------------------
IS BASED ON FINDINGS OF LAB ANIMAL
-----------------------------
EPIDEMIOLOGICAL STUDIES THAT WERE CONSIDERED LIMITED
-----------------------------
DISEASE. CS HAS NOT BEEN CLASSIFIED AS CARCIN
-----------------------------
HNDLG PACKAGED PAINT PROD CNTNG PRE-
-----------------------------
DRIED PAINT FILM DUE TO PRESENCE OF CS.
-----------------------------
HASKEL TOX LAB FOUND EVID OF LUNG CANCER
-----------------------------
FEMALE RATS AFTER THEY WERE EXPOSED TO
-----------------------------
-----------------------------
INFORMATION CONT NEHC (FP N).
-----------------------------
-----------------------------
INDUCE VOMIT. CONSULT PHYS/POIS CTRL CTR
-----------------------------
-----------------------------
INFO CONT NEHC (FP N).
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE: EXCESS INHAL OF VAPS CAN CAUSE NASAL & RESP
IRRIT, DIZZ, WEAK, FATG, NAUS &/OR HDCH. OVEREXP CAN CAUSE NEUROLOGICAL
DMG. INHAL: MISTS/VAPS FROM HOT OPERATIONS CAN CAUSE MENTAL SLUGGISHNESS, PUL
M EDEMA (ACCUM OF FLUID IN LUNGS, SIGNS& SYMPS CAN BE DELAYED FOR SEVERAL
HRS) & BRONCHIAL PNEUM. (EFTS OF OVEREXP)
Signs And Symptions Of Overexposure: HLTH HAZ: SKIN: DUE TO INDIVIDUAL
SENSITIZ, PROD CAN CAUSE SKIN IRRIT UPON PRLNGD/RPTD CONT. EYES: TRACE AMTS
OF AMINE & RESIDUAL MONOMER VAPS MAY BE IRRIT TO EYES ESPECIALLY IN
POORLY VENTILATED AREA S. IRRIT IN FORM OF REDNESS, TEARING &/OR BLURRED
VISION. EYE CONT: VAPS CAN CAUSE SEV CONJ. INGEST: CAN CAUSE (SUPDAT)
Medical Cond Aggravated By Exposure: EFTS OF RPTD OVEREXP. NO EVIDENCE OF
ADVERSE EFTS FROM AVAIL INFO. NOTICE: RPTS HAVE ASSOC RPTD & PRLNGD OCCUP
OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG. INTENTIONAL MISUSE BY DELIB
CONC
First Aid: INHAL: INDIVIDUAL MAY EXPERIENCE DIZZ/LT HEAD WHEN WORKING IN AREAS
OF HIGH VAP CONCS. VICTIM SHOULD SEEK AIR FREE OF VAPS. IF BRTHG STOPS, BEGIN
ARTF RESP & SEEK IMMED MED ATTN. SKIN: THORO WASH AREA W/SOAP & LG
& LOWER LIDS OCCASNLY.
*
Handling and Disposal
*
Spill Release Procedures: ELIM ALL IGNIT SOURCES (FLARES, FLAMES INCL PILOT
LIGHTS, ELEC SPKS). RECOVER FREE PROD. ADD SAND, EARTH/OTHER SUITABLE ABSORB
TO SPILL AREA. MINIMIZE SKIN CONT. VENTILATE CONFINED SPACES. KEEP PROD O UT
OF SEWERS & WATERCOURSES BY DIKING OR
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF PRODUCT IN ACCORDANCE WITH APPLICABLE LOCAL,
COUNTY, STATE AND FEDERAL REGULATIONS.
Handling And Storage Precautions: KEEP FROM FREEZING. KEEP OUT OF REACH OF
CHILDREN.
Other Precautions: DO NOT TAKE INTERNALLY.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: CLASS B EXTINGUISHER. USE FOAM, CARBON DIOXIDE OR DRY
CHEMICAL FIRE FIGHTING APPARATUS.
Fire Fighting Procedures: NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N). WATER
MAY BE UNSUITABLE AS EXTING MEDIA, BUT HELPFUL IN KEEPING ADJACENT CNTNRS
COOL. AVOID SPREADING (SUPDAT)
Unusual Fire/Explosion Hazard: VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND/BE MOVED BY VENT TO LOCATIONS DISTANT FROM HNDLG POINT. NEVER USE
WELDING/CUTTING TORCH ON OR NEAR CONTAINER (SUPDAT)
*
*
Respiratory Protection: THE USE OF RESPIRATORY PROTECTION DEPENDS ON VAPOR
CONCENTRATION ABOVE THE TIME WEIGHTED TLV: USE NIOSH APPROVED RESPIRATOR.
Ventilation: PROVIDE SUFFICIENT MECHANICAL (GENERAL) AND/OR LOCAL EXHAUST
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: DO NOT EAT, DRINK OR SMOKE WHILE USING THIS PRODUCT.
THOROUGHLY WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health: MFR TRADE NAME/PART NO: LATEX FLAT WALL PAINT.
FIRE FIGHT PROC: BURNING LIQ W/WATER USED FOR COOLING. EXPLO HAZ:(EVEN EMPTY)
BECAUSE VAPS MAY IGNITE. EFTS OF OVEREXP: GI IRRIT, NAUS, VOMIT & DIARR.
AS PIR OF MATL INTO LUNGS CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL. ETHYLENE
GLYCOL:TOXIC DATA:INGEST:SLIGHTLY TOXIC
*
Physical/Chemical Properties
*
PH: 7.6
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: INFINITELY
Appearance and Odor: VISCOUS LIQUID. MILD ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: THIS PROD IS INCOMPATIBLE WITH STRONG OXIDIZING AGENTS,
STRONG ACIDS OR BASES AND SELECTED AMINES.
Hazardous Decomposition Products: THERMAL DECOMPOSITION IN PRESENCE OF AIR MAY
YIELD CARBON MONOXIDE AND/OR CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
GRAMS/LITER).
*
HAZCOM Label
*
Company Name: DURON INC
Label Required IND: Y
Status Code: C
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EXCESS INHAL OF VAPS CAN CAUSE NASAL & RESP
IRRIT, DIZZ, WEAK, FATG, NAUS &/OR HDCH. OVEREXP CAN CAUSE NEUROLOGICAL
DMG. INHAL: MISTS/VAPS FROM HOT OPERATIONS CAN CAUSE MENTAL SLUGGISHNESS, PUL
M EDEMA (ACCUM OF FLUID IN LUNGS, SIGNS& SYMPS CAN BE DELAYED FOR SEVERAL
HRS) & BRONCHIAL PNEUM. SKIN: CAN CAUSE IRRITATION. EYES: CAN CAUSE
IRRITATION, REDNESS, TEARING, BLURRED VISION AND CONJUNCTI VITIS. INGESTION:
GI IRRIT, NAUS, VOMIT & DIARRHEA. ASPIRATION HAZARD. CHRONIC: CANCER
HAZARD. CONTAINS CRYSTALLINE SILICA WHICH IS LISTED AS A HUMAN LUNG CARCIN
(FP N). OVEREXPOSURE HAS BEEN REPORTED TO CAUSE PERM BRAIN AND NERV SYSTEM
DAMAGE.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SELF-CONTAINED BREATHING APPARATUS W/FULL
FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE-PRESSURE
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO KEEP <TLV.
Other Protective Equipment:PROVIDE AN EYE-WASH FOUNTAIN WITH THE
IMMEDIATE WORK AREA.
Supplemental Safety and Health
POISONING MAY CAUSE HYPOMAGNESEMIA/HYPOCALCEMIA RESULTING IN TETANY
ESPECIALLY OF EXTREMITIES/MUSCLE
SPASMS/CONVULSIONS/PARASTHESIAS/HYPOTENSION/SHOCK/SINUS
TACHYCARDIA/CARDIAC ARRHYTHMIAS/MULTIPLE AT TACTKS OF VENTRICULAR
FIBRILLATION/DEATH. REPEATED/PROLONGED EXPOSURE TO LOW VAPOR LEVELS
MAY CAUSE CONJUNCTIVITIS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:HYDROGEN FLUORIDE (SARA III)
Other REC Limits:2.5 PPM
OSHA PEL:3 PPM/6 STEL (F)
Ingred Name:WATER, H2O
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: FEVER, COUGH, DYSPNEA,
CYANOSIS, & PULMONARY EDEMA OR BRONCHOPNEUMONIA. CORROSIVE/HIGHLY
TOXIC. HIGH LELS MAY CAUSE ULCERATIVE
TRAACHEOBRONCHITIS/HEMORRHAGIC PULMONARY EDEMA. SKIN/EYES: IR
RITATION, BURNS, BLINDNESS. INGESTION: NAUSEA, VOMITING, DIARRHEA,
CONVULSIONS, DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:HYDROGEN FLUORIDE IS A HIGHLY TOXIC, SEVERE
EYE, MUCOUS MEMBRANE & SKIN IRRITANT. POISONING AFFECTS THE BRAIN,
KIDNEYS, CARDIOVASCULAR, NEUROMUSCULAR, & GASTROINTESTINAL SYSTEM.
CHRONIC EXPOSURE MAY P RODUCE FLUOROSIS OF SKELETAL SYSTEM.
INHALATION: SYMPTOMS CENTRAL
NERVOUS/HEADACHE/SALIVATION/COMA/CONVULSIONS/DEATH.
Medical Cond Aggravated by Exposure:DEATH FROM PULMONARY EDEMA OCCURED
PROMPT SHOWERING.
* First Aid Measures *
First Aid:INHALATION: REMOVE FROM EXPOSURE AREA TO FRESH AIR. IF
BREATHING HAS STOPPED, GIVE ARTIFICIAL RESPIRATION. KEEP AFFECTED
PERSON WARM/AT REST. SKIN: REMOVE CONTAMINATED CLOTHING/SHOES. WASH
AFFECTED AR EA W/SOAP OR MILD DETERGENT/LARGE AMTS OF WATER. EYES:
WASH W/LARGE AMTS OF WATER. INGESTION: IF VICTIM IS CONSCIOUS, GIVE
LARGE QTYS OF WATER TO DILUTE THE ACID. DON'T INDUCE VOMITING. GET
MED ATTN.
* Fire Fighting Measures *
Flash Point:NONFLAMMABLE
Extinguishing Media:DRY CHEMICAL, CO2, WATER SPRAY, FOG OR ALCOHOL
FOAM.
Fire Fighting Procedures:DON'T GET WATER INSIDE CONTAINER. MOVE
CONTAINER FROM FIRE AREA IF POSSIBLE. COOL FIRE-EXPOSED CONTAINERS
W/WATER FROM SIDE UNTIL WELL AFTER FIRE IS OUT.
Unusual Fire/Explosion Hazard:ISOLATE AREA UNTIL GAS HAS DISPERSED.
SLIGHT FIRE HAZARD WHEN EXPOSED TO HEAT OR FLAME.
* Accidental Release Measures *
Spill Release Procedures:STOP LEAK IF YOU CAN DO IT W/O RISK. USE WATER
SPRAY TO REDUCE VAPORS BUT DON'T PUT WATER ON LEAK OR SPILL AREA.
ISOLATE AREA UNTIL GAS HAS DISPERSED. FOR LARGE SPILLS, DIKE FAR
AHEAD OF SPILL FOR LAT ER DISPOSAL. EVACUATE AREA ENDANGERED BY
GAS.
Neutralizing Agent:SLAKED LIME, SODIUM BICARBONATE OR CRUSHED LIMESTONE
*Handling and Storage *
Handling and Storage Precautions:DON'T GET WATER INSIDE CONTAINER. MOVE
CONTAINER FROM FIRE AREA IF POSSIBLE. AVOID BREATHING CORROSIVE
VAPORS.
* Physical/Chemical Properties *
Vapor Density:0.7
Spec Gravity:1.1-1.2
pH:ACID
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS, FUMING LIQUID WITH A PUNGENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REACTS EXOTHERMICALLY W/WATER. CORROSIVE TO GLASS, SILICEOUS MATERIALS,
METALS, CYANOGEN FLUORIDE, ARSENIC/CALCIUM OXIDE
Stability Condition to Avoid:HEAT, FLAME
Hazardous Decomposition Products:MAY RELEASE CORROSIVE HYDROGEN
FLUORIDE, HYDROGEN GAS.
* Disposal Considerations *
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT USUALLY REQUIRED.
Ventilation:LOCAL EXHAUST, MECHANICAL.
Other Protective Equipment:EYE BATH, SAFETY SHOWER, APRONS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. TREAT MATERIAL IAW/GOOD MANUFACTURING PRACTICE.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:BARRY FIELDING
* Composition/Information on Ingredients *
Ingred Name:ORANGE OIL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE THROAT & LUNG
IRRITATION. SKIN/EYES: MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/COPIOUS
RINSE MOUTH W/WATER. DRINK MILK. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. FLUSH W/DETERGENT &
WATER/ABSORB FREE MATERIAL ON SAWDUST, SAND/OTHER ABSORBENT
MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED. KEEP AWAY FROM
IGNITION SOURCES. STORE IN COOL, DRY PLACE PROTECTED FROM LIGHT.
PROVIDE ADEQUATE VENTILATION.
Other Precautions:AVOID CONTACT W/SKIN.
* Physical/Chemical Properties *
Solubility in Water:SLIGHT
Appearance and Odor:YELLOW TO DEEP ORANGE LIQUID W/TYPICAL FRESH ORANGE
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:BY BURNING: CO, CO2 & SMOKE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
*
| 1 | gloves_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Item Description Information
*
*
Ingredients
*
< Wt: 1.
OSHA PEL: 1 MG/M3
ACGIH TLV: 1 MG/M3
ACGIH STEL: 3 MG/M3
------------------------------
< Wt: .1
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE REPORTED.
First Aid: INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) (FP N). EYES: IMMEDIATELY FLUSH EYES WITH
WATER. INGESTION: DO NOT INDUCE VOMITING. GIVE 1-2 GLASSES OF WATER. CALL MD
IMMEDIATELY. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
*
Handling and Disposal
*
Spill Release Procedures: COVER THE CONTAMINATED SURFACE WITH SODIUM
NECESSARY TO FORM A SLURRY. SCOOP UP SLURRY AND WASH SITE WITH SODA ASH
SOLUTION. T HE NEUTRALIZED SLURRY MAY CONTAIN SUFFICIENT HEAVY METAL
CONCENTRATION TO REQUIRE LANDFILLING OR TREATENT AT AN EPA APPROVED SITE.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND
LOCAL REGULATIONS.
Handling And Storage Precautions: STORE TIGHTLY CLOSED IN A COOL, DRY PLACE.
Other Precautions: AVOID CONTACT WITH EYES AND SKIN. DO NOT BREATHE MIST OR
VAPOR. WASH THOROUGHLY AFTER HANDLING.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT.
*
*
Respiratory Protection: USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: ADEQUATE VENTILATION.
(FP N).
Other Protective Equipment: EMERGENCY EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N). LAB COAT.
Supplemental Safety and Health: ANY COMPONENT OF THIS MIXTURE NOT SPECIFICALLY
LISTED (EG, "OTHER COMPONENTS") IS NOT CONSIDERED TO PRESENT A CARCINOGEN
IN /YR.
*
Physical/Chemical Properties
*
Vapor Pres: NOT DETERMINED
Vapor Density: NOT DETERM
PH: 1.4
Evaporation Rate & Reference: NOT DETERMINED
Solubility in Water: MISCIBLE
Appearance and Odor: CLEAR AND COLORLESS LIQUID; NO ODOR.
Corrosion Rate: SUPDAT
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE REPORTED.
*
Toxicological Information
*
*
*
*
Regulatory Information
*
CORROSIVE.
*
Other Information
*
IN/YR.
*
HAZCOM Label
*
Assigned IND: Y
Company Name: DREW INDUSTRIAL DIVISION
Street: ONE DREW PLAZA
Label Required IND: Y
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: THIS PRODUCT MAY BE: CORROSIVE TO EYES,
IRRITATING TO SKIN. EYE BURNS, SKIN IRRITATION. CHRONIC: CANCER HAZARD.
CONTAINS SULFURIC ACID WHICH IS LISTED AS AN ANIMAL PULMONARY CARCINOGEN (FP
N) .
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
APPROVED RESPIRATOR WHEN NECESSARY.
Ventilation:USE PROCESS ENCLOSURE, LOC EXHST VENT/OTHER ENGINEERING
CONTROLS TO CONTROL AIRBORNE LEVELS BELOW REC EXPOSURE LIMITS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . USE APPROP PROT CLTHG TO PREVENT SKIN EXPOS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING & WASH BEFORE REUSE.
Supplemental Safety and Health
EXTING MEDIA:ALCOHOL-RESIST FOAM. EFTS OF OVEREXP:INHAL. TARGET
ORGANS:KIDNEYS, CNS, LIVER, RESP SYS. FIRST AID PROC:NOT BRTHG,
GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYG. NOTES TO MD:TREAT
SYMPTOMA TICALLY & SUPPORTIVELY. EYE PROT:& FULLLENGTH FACESHIELD .
MATLS TO AVOID:CHROMYL CHLORIDE, NITROSYL (ING 2)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SUPP DATA:CHLORIDE, HEXACHLOROMELAMINE, NITROSYL
PERCHLORATE, NITRYL PERCHLORATE, PERMONOSULFURIC ACID, (ING 3)
Ingred Name:ING 2:THIODIGLYCOL + HYDROGEN PEROXIDE.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:PRDCES IRRIT, CHARACT BY
BURNING SENSATION, REDNESS, TEARING, INFLAMM & POSS CORNEAL INJURY.
SKIN:EXPOS MAY CAUSE IRRIT CHARACT BY REDNESS, DRYNESS & INFLAMM.
INGEST:MAY CAUSE IRRIT OF DIGES T TRACT. MAY CAUSE CNS DEPRESS,
KIDNEY DMG & LIVER DMG. SYMPS MAY INCL:HDCH, EXCITEMENT, FATG,
NAUS, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:VOMIT, STUPOR & COMA. INHAL:INHAL OF
HIGH CONCS MAY CAUSE CNS EFTS CHARACT BY HDCH, DIZZ, UNCON & COMA.
CAUSES RESP TRACT IRRIT. MAY CAUSE LIVER & KIDNEY DMG. MAY CAUSE
MOTOR INCOORD & SPEECH ABNORMS. CHRONIC:PRLNG/RPTD SKIN CONT MAY
CAUSE DERM. CHRONIC INHAL MAY CAUSE EFTS SIMILAR TO THOSE OF ACUTE
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN:FLUSH W/PLENTY
SHOES. GET ME D AID IF IRRIT DEVELOPS/PERSISTS. INGEST:IF VICTIM IS
CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. GET MED AID
IMMED. INHAL:GET MED AID IMMED. REMOVE FROM EXPOS TO FRESH AIR
IMMED. IF (SUPDAT)
* Fire Fighting Measures *
Lower Limits:2.5%
Extinguishing Media:FOR SM FIRES, USE DRY CHEM, CARBON DIOXIDE, WATER
SPRAY/ALCOHOL-RESIST FOAM. FOR LG FIRES, USE WATER SPRAY,
FOG/(SUPDAT)
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:CONTAINERS CAN BUILD UP PRESSURE IF
EXPOSED TO HEAT &/OR FIRE. VAPORS CAN TRAVEL TO A SOURCE OF
IGNITION & FLASH BACK.
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PPE AS INDICATED IN EXPOSURE
CONTROLS, PERSONAL PROT SECTION. ABSORB SPILL W/INERT MATL, (E.G.,
DRY SAND OR EARTH), THEN PLACE INTO CHEMICAL WASTE CONTAINER. WEAR
APPROP PROT CLTHG TO MINIM IZE CONT W/SKIN. REMOVE ALL SOURCES OF
IGNITION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNITION.
STORE IN TIGHTLY CLOSED CONTAINERS. USE W/ADEQUATE VENTILATION.
AVOID CONTACT W/EYES, SKIN & CLOTHING.
Other Precautions:DANGER! EXTREMELY FLAMMABLE LIQUID. EMPTY CONTAINERS
RETAIN PRODUCT RESIDUE (LIQUID &/OR VAPOR), & CAN BE DANGEROUS. DO
NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL, GRIND OR EXPOSE
EMPTY CONTAINER S TO HEAT, SPARKS OR OPEN FLAMES.
* Physical/Chemical Properties *
Vapor Density:2.0
pH:7
Evaporation Rate & Reference:7.7 (N-BUTYL ACETATE=1)
Solubility in Water:SOLUBLE
Appearance and Odor:COLOURLESS LIQUID; SWEETISH ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
FORMS EXPLO MIXTS W/HYDROGEN PEROXIDE, ACETIC ACID, NITRIC ACID, NITRIC
ACID + SULFURIC ACID, CHROMIC ANHYDRIDE,(SUPDAT)
Stability Condition to Avoid:HIGH TEMPERATURES, TEMPERATURES ABOVE
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT W/FEDERAL,
WASTE).
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:LOCAL EXHAUST IS PREFERRED TO KEEP VAPORS/PARTICULATES
BELOW THE TLV. MECHANICAL AREAWIDE VENTILATION IS ACCEPTABLE.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
THIS PRODUCT IS UNALTERED WOULD HAVE THE FOLLOWING HAZARDOUS WASTE
OTHER CODES MAY BE RELEVANT. THIS IS PART D OF A FIVE-PART KIT.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:MAGNESIUM OXIDE
Fraction by Wt: 1.3%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 4.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
Other REC Limits:NONE RECOMMENDED
Ingred Name:NAPHTHA, LIGHT ALIPHATIC
Other REC Limits:NONE RECOMMENDED
Ingred Name:TOLUENE (SARA III)
Other REC Limits:NONE RECOMMENDED
Ingred Name:HEXANE (N-HEXANE)
Fraction by Wt: 9.3%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CENTRAL NERVOUS SYSTEM DISTURBANCES,
GASTROINTESTINAL DISTURBANCES, DERMATITIS, KIDNEY/LIVER DAMAGE,
RESPIRATORY DISTURBANCES
Explanation of Carcinogenicity:PRODUCT CONTAINS NO INGREDIENTS
CURRENTLY CLASSIFIED AS CARCINOGENIC BY NTP, IARC OR OSHA.
Effects of Overexposure:IRRITATION, DIZZINESS, GIDDINESS, WEAKNESS,
DROWSINESS, LETHARGY, BREATHING DIFFICULTIES, DEFATTING, HEADACHE,
INCOORDINATION, NAUSEA, DIARRHEA, VOMITING, NARCOSIS. CHRONIC
EFFECTS: DERMATITIS, CENTRA L NERVOUS SYSTEM PROBLEMS,
KIDNEY/LIVERDAMAGE
Medical Cond Aggravated by Exposure:SKIN ALLERGIES, CARDIOVASCULAR
DISEASES MAY BE AGGRAVATED BY EXPOSURE.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
CALL A PHYSICIAN. SKIN: WASH WITH SOAP AND WATER. EYES: FLUSH WITH
CONTACT A PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CARBON DIOXIDE
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING WHEN FIGHTING FIRE.
Unusual Fire/Explosion Hazard:COMBUSTION MAY RELEASE TOXIC GASES AND
FUMES.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. SOAK UP
LIQUID WITH AN ABSORBENT MATERIAL SUCH AS SAND, EARTH, SWEEPING
COMPOUND OR SOME OTHER ABSORBENT MATERIAL. PACKAGE ABSORBENT
MATERIAL OR SOLID PRODUCT IN STE EL DRUMS WHICH ARE IN GOOD
CONDITION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
FROM SUNLIGHT AND ANY SOURCE OF HEAT, SPARKS OR FLAME. KEEP
CONTAINER TIGHTLY CLOSED WHEN NOT BEING USED.
Other Precautions:USE WITH ADEQUATE VENTILATION, AVOID PROLONGED OR
REPEATED BREATHING OF VAPORS. AVOID SKIN CONTACT. USE IN ANREA FREE
FROM FLAME AND SPARKS.
* Physical/Chemical Properties *
HCC:F2
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Evaporation Rate & Reference:4.4 (BUTYL ACETATE = 1)
Solubility in Water:MODERATE
Appearance and Odor:BLACK COLORED LIQUID WITH NON-RESIDUAL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, HALOGENS, STRONG ALKALIS, STRONG ACIDS, STRONG
MINERAL ACIDS, AMINES, AMMONIA
Stability Condition to Avoid:AVOID EXTREME TEMPERATURES, SUNLIGHT AND
IGNITION SOURCES
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
NITROGEN OXIDES, HYDROGEN CHLORIDE
* Disposal Considerations *
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. WEAR NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:POLYPROPYLENE
Fraction by Wt: 4.5%
Ingred Name:ORGANIC PIGMENT. CONSISTING OF ING 5, 6, & 7.
Fraction by Wt: 2%
Ingred Name:DYE
Ingred Name:DYE
Ingred Name:DYE
Ingred Name:IRON OXIDE
Fraction by Wt: 1%
ACGIH TLV:5 MG/M3 (FE)
Ingred Name:CARBON BLACK
Fraction by Wt: 6.5%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:STYRENE-ACRYLATE COPOLYMER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MINIMAL IRRITATION TO RESPIRATORY
TRACT MAY OCCUR AS WITH EXPOSURE TO ANY NON-TOXIC DUST. LDLO VALUE
OF THIS TONER IN AN ORAL ACUTE TOXICITY TEST IS >5G/KG.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ACCUMULATION OF DUST IN RESPIRATORY
SYSTEM.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . SKIN: FLUSH WITH COPIOUS AMOUNTS
OF WATER. CALL MD . INHAL:REMOVE TO FRESH AIR IF EFFECTS OCCUR,
CONSULT LOCAL MEDICAL PERSONNEL. EYES:IMMEDIATELY FLUSH WITH W ATER
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM OR WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS MATERIAL HAS NO UNUSUAL FIRE OR
EXPLOSION HAZARDS.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP OR CLEAN UP WITH A VACUUM CLEANER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:NO SPECIAL STORAGE REQUIREMENTS FOR
SAFETY REASONS.
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FINE BLACK POWDER WITH NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO, CO2 & NOX.
* Disposal Considerations *
Waste Disposal Methods:WASTE MATERIAL MAY BE DUMPED OR INCINERATED
UNDER CONDITIONS WHICH MEET ALL LOCAL, STATE AND FEDERAL
ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
Control Measures
*
*
Contractor Summary
*
Box: NK/
*
Ingredients
*
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:EYES:DUST FROM ABRADED SURFACE MAY CAUSE MECHANICAL
IRRITATION. SKIN/INGESTION:NO ADVERSE HEALTH EFFECTS EXPECTED.
INHALATION:OVEREXPOSURE TO DUST FROM ABRADED SURFACE MAY CAUSE RESPIRATORY
SYST EM IRRITATION. HAZARD DEGREE BASED ON MATERIAL BEING ABRADED.
CHRONIC:NOT AVAILABLE.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NOT AVAILABLE.
First Aid: INGEST:CALL MD IMMEDIATELY (FP N). SKIN:FLUSH W/COPIOUS AMOUNTS OF
& CALL MD IF IRRITATION PERSISTS. INHAL:PROVIDE FRESH AIR , TREAT FOR
SUBSTRATE MATERIAL BEING ABRADED.
*
Handling and Disposal
*
Spill Release Procedures: NO SPECIAL PROCEDURES.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: COLLECT MATERIAL & DISPOSE IN A LOCAL SANITARY
LANDFILL. FOLLOW FEDERAL, STATE & LOCAL REGULATIONS.
Handling And Storage Precautions: KEEP CONTAINER CLOSED. NO SPECIAL HANDLING
PRECAUTIONS.
Other Precautions: AVOID BREATHING DUST FROM MATERIAL BEING GROUND. PREVENT
SKIN OR EYE CONTACT W/DUST CREATED FROM GRINDING SUBSTRATE. NO UNUSUAL FIRE
OR SPILL HAZARD; NUISANCE-LEVEL HEALTH RISK.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NONE
Lower Limits: NONE
Upper Limits: NONE
Extinguishing Media: WATER, CARBON DIOXIDE, FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NON-FLAMMABLE.
*
*
Respiratory Protection: WEAR A NIOSH APPROVED PARTICULATE FACE MASK WHERE DUST
IS GENERATED.
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
*
Physical/Chemical Properties
*
Appearance and Odor: SOLID ABRASIVE PRODUCT; NO ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NOT DETERMINED.
Hazardous Decomposition Products: THERMAL DEGRADATION WILL PRODUCE CARBON
MONOXIDE, CARBON DIOXIDE & SMOKE PARTICULATES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Assigned IND: Y
Company Name: LECO CORPORATION
PO Box: NK/
Label Required IND: Y
Status Code: C
Origination
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:EYES:DUST FROM ABRADED SURFACE MAY CAUSE
MECHANICAL IRRITATION. INHALATION:OVEREXPOSURE TO DUST FROM ABRADED SURFACE
MAY CAUSE RESPIRATORY SYSTEM IRRITATION. HAZARD DEGREE BASED ON MATERIAL BEIN
G ABRADED. CHRONIC:NONE LISTED BY MANUFACTURER.
*
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Supplemental Safety and Health
SPILLS CONT'D: VENTILATE AREA & WASH SITE AFTER MATERIAL PICKUP IS
COMPLETE.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:OXAZEPAM-PHENYL-D5
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE FATAL/CAUSE BLINDNESS IF
SWALLOWED. VAPOR HARMFUL. CAUSES IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MAY BE FATAL/CAUSE BLINDNESS IF SWALLOWED.
VAPOR HARMFUL. CAUSES IRRITATION.
* First Aid Measures *
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. SHUT OFF IGNITION SOURCES. WEAR
SAND/SODA ASH. PLACE IN COVERED CONTAINERS USING NON-SPARKING TOOLS
& TRANSPORT OUTDOORS. PLA CE IN APPROPRIATE CONTAINER. (SEE SUPP)
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM IGNITION SOURCES.
Other Precautions:DON'T BREATHE VAPOR. NO SMOKING. POISON & TOXIC.
CAN'T BE MADE NON-POISONOUS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:IGNITION SOURCES.
* Disposal Considerations *
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED
W/AFTERBURNER & SCRUBBER BUT EXERT EXTRA CARE IN IGNITING AS THIS
MATERIAL IS HIGHLY FLAMMABLE. DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED MECHANICAL FILTERS
DESIGNED TO REMOVE PARTICLES WHEN APPLYING BY SPRAY.
Ventilation:MAINTAIN SUFFICIENT VENTILATION TO KEEP AIR CONTAM CONC
BELOW OSHA PERMISSIBLE EXPOSURE LEVEL.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING. SMOKE IN
AUTHORIZED AREAS ONLY.
Supplemental Safety and Health
OTHER PREC: PIGMENT DUSTS. PROVIDE ADEQUATE VENTILATION AND WEAR
NIOSH/MSHA APPROVED RESPIRATORY PROTECTION IF SANDING. EXPLAN
CARCIN: OXIDE: GROUP 2A (IARC), GROUP 2 (NTP), OSHA REGULATED.
* Product Identification *
Preparer's Name:K.TRAUTWEIN
* Composition/Information on Ingredients *
Ingred Name:ETHYLENE GLYCOL (SARA III)
Fraction by Wt: 3%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHAL: TRACE COMPONENT & RESIDUAL
MONOMER VAPS MAY BE IRRIT TO EYES, SKIN, MUC MEMB, RESP TRACT, &
MAY PRDCE SYMP OF HDCH, NAUS IN POORLY VENT AREAS. SKIN: PRLNGD
CONTACT MAY CAUSE TRANSIENT REDDENING OF SKIN. EYE: MAY CAUSE
IRRIT. SKIN ABSORP: NO EVIDENCE OF ADVERSE EFTS FROM AVAIL
INFORMATION. (SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:FORMADEHYDE: GROUP 2A (IARC), GROUP 2
(NTP), OSHA REGULATED. CRYSTALLINE SILICA: GROUP 2A (IARC).
ETHYLENE (SUPP DATA)
Effects of Overexposure:HLTH HAZ: INGEST: NONE EXPECTED. MAY CONTAIN
TRACE AMOUNTS OF FORMALDEHYDE AND CRYSTALLINE SILICA WHICH ARE
CONSIDERED CARCINOGENIC. TRACE AMOUNTS OF ETHYLENE OXIDE MAY BE
PRESENT WHICH IS CARCINOGENI C AND A REPRODUCTIVE TOXIN.
Medical Cond Aggravated by Exposure:NONE EXPECTED.
* First Aid Measures *
MINUTES. TAKE TO PHYS FOR MEDICAL TREATMENT. INGEST: DRINK 1 OR 2
GLASSES OF WATER TO DILUTE. DO NOT INDUCE VOMITING. CONSUL PHYS
IMMED. S KIN: REMOVE WITH SOAP AND WATER. INHAL:REMOVE TO FRESH
AIR. SUPPORT BREATHING (GIVE ARTF RESP/O2). CALL MD IMMED .
* Fire Fighting Measures *
Lower Limits:3.2%
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NON-FLAMMABLE. AFTER WATER EVAPORATES, REMAINING
MATERIAL WILL BURN.
Unusual Fire/Explosion Hazard:PRODUCT WILL NOT BURN BUT MAY SPATTER IF
TEMPERATURE EXCEEDS BOILING POINT OF WATER. DRIED SOLIDS CAN BURN,
GIVING OFF OXIDES OF CARBON.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN MATERIAL & SCRAPE OR USE ABSORBANT
MATERIAL TO CLEAN UP. TRANSFER TO CONTAINERS FOR DISPOSAL. WASH
AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CLOSURE TIGHT & CNTNR UPRIGHT TO
PVNT LEAKAGE. PROTECT FROM FREEZING. DO NOT TAKE INTERNALLY, &
AVOID PRLNGD SKIN CONTACT/INHAL.
Other Precautions:REPORTS HAVE ASSOCIATED RPTD & PRLNGD OCCUPATIONAL
OVEREXPOS TO SOLV W/PERM BRAIN & NERVOUS SYS DAMAGE. INTENTIONAL
MISUSE BY DELIBERATELY CONC & INHAL CONTENTS MAY BE FATAL. SANDING
OF DRIED PAINT FI LM WILL RSLT IN EXPOS TO (SEE SUPP DATA)
* Physical/Chemical Properties *
HCC:N1
Vapor Density:LRT/AIR
Spec Gravity:1.2
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:DILUTABLE.
Appearance and Odor:OPAQUE LIQUID WITH MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID MATERIALS THAT REACT WITH WATER.
Stability Condition to Avoid:AVOID FREEZING CONDITIONS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION OR BURNING MAY
PRODUCE CARBON MONOXIDE & CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROP, PROPERLY FITTED
RESPIRATOR IF EXPOSURES EXCEED PEL/TLV VALUES. TYPE OF PROTECTION
SELECTED WILL DEPEND UPON CONDITIONS OF USE. OBSERVE OSHA
Ventilation:PROVIDE EFFECTIVE MECH EXHST VENT TO DRAW VAPS, MISTS/FUMES
Other Protective Equipment:PROPER CHEMICAL-RESISTANT APRON AND
ADDITIONAL IMPERVIOUS CLTHG TO PVNT SKIN CONTACT & CONTAM OF CLTHG.
Work Hygienic Practices:NORMAL WORK CLTHG SHD BE WASHED BEFORE RE-USE.
WASH HANDS/FACE THORO AFTER HNDLG PROD & BEFORE
EATING/DRINKING/SMOKING.
Supplemental Safety and Health
FIRE FIGHT PROC: FIRE FROM SAFE DISTANCE. CNDTNS (STAB): OR EXPOS TO
INCOMPAT SUBSTANCES. MATLS TO AVOID: CAUSE HAZ POLYMERIZATION. HAZ
DECOMP PRODS: MAY CAUSE UNCONTROLLED EXOTHERMIC RXNS RSLTG IN DE
COMP & CHARRING OF MATL. FUMES/VAPS FROM THERM/CHEM DECOMP MAY VARY
WIDELY IN COMPOSITION & TOXICITY.
* Product Identification *
Preparer's Name:DAVID HAAS
CAGE:0JMR7
CAGE:0JMR7
* Composition/Information on Ingredients *
Ingred Name:ING 8: WATERWAYS. TRANSFER ABSORBED MATERIAL AND WATER
RINSES TO APPROPRIATE WASTE CONTAINERS.
Ingred Name:VENT:ROUTINE INHAL.THIS IS NEC ESPEC DURING ELEVATED TEMP
Ingred Name:OTHER PROT EQUIP: EYE WASH FACILITIES AND SAFETY SHOWER
SHOULD BE AVAILABLE.
Ingred Name:EPOXY RESIN
Ingred Name:CURING AGENT
OSHA PEL:1 PPM (MFR)
ACGIH TLV:1 PPM (MFR)
Ingred Name:EFTS OF OVEREXP: OBSERVED IN CULTURED CAT LIVER CELLS.
Ingred Name:FIRST AID PROC:MED ATTN. INGEST: DILUTE BY GIVING PLENTY OF
H*2O TO DRINK, IF VICTIM IS CONSCIOUS & ALERT. NEVER (ING 5)
Ingred Name:ING 4: GIVE ANYTHING BY MOUTH TO DROWSY, UNCONSCIOUS, OR
CONVULSING PERSON. GET IMMEDIATE ATTENTION.
Ingred Name:SPILL PROC: TO IMMED SPILL AREA. SHUT OFF SOURCE OF RELS IF
CAN BE DONE W/OUT RISK OF INJ. ACTIVATE AVAIL EXHST (ING 7)
Ingred Name:ING 6:VENT SYS IN AREA. DIKE AREA TO CONTAIN SPILL & PVNT
RELS TO SEWERS, DRAINS/OTHER WATERWAYS. COLLECT SPILLED(ING 8)
Ingred Name:ING 7:MATL FOR SALVAGE/DISP.APPLY ABSORB MATL TO SOAK UP
RESIDUE.WASH AREA W/SOAPY H*2O.PVNT RUNOFF FROM ENTERING(ING 9)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:(ACUTE) EYE: IRRIT TO EYES. SYMP MAY
INCL BLURRED VISION, BURNING SENSATION & TEARING. SKIN: MODERATE
SKIN IRRIT. PRLNGD/RPTD EXPOS TO LIQ MAY EXERT DEFAT/DRY ACTION ON
SKIN, POSS RSLTG IN DERM. MAY C AUSE SKIN SENSIT/ALLERGIC SKIN RXNS
WHICH MAY BE SEV IN CERTAIN INDIV; SYMP INCL RASH, ITCHING, HIVES,
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SWELLING OF EXTREM. INHAL:HEATING CAN
GENERATE VAPS THAT MAY CAUSE RESP IRRIT,NAUS & HDCH.INHAL HAZ AT
ROOM TEMP IS UNLIKELY,DUE TO LOW VOLATILITY OF PROD.INGEST: HARMFUL
IF SWALLOWED. (CHRON IC)DGEBA EPOXY RESIN IN PROD HAS BEEN SHOWN TO
BE MUTAGENIC IN SOME MICROBIAL TESTS, CHROMOSOMEL ABERRATIONS
WERE(ING 3)
Medical Cond Aggravated by Exposure:EXPOSURE MAY AGGRAVATE PREEXISTING
SKIN AND/OR EYE DISORDERS.
* First Aid Measures *
HOLDING EYELIDS OPEN. GET MED ATTN. SKIN: REMOVE ANY CONTAM CLTHG &
FLUSH AFFECTED AREA OF SKIN THORO W/PLENTY OF H*2O. FOLLOW BY
WASHING W/SOAP & H*2O. GET MED ATTN IF IRRIT PERSISTS.DO NOT REUSE
CONTAM CLTHG UNTIL PROPERLY CLEANED. INHAL: REMOVE VICTIM TO FRESH
AIR. PROVIDE O*2 IF BRTHG DFCLT. GIVE ARTF RESP IF NOT BRTHG. GET
IMMED (ING 4)
* Fire Fighting Measures *
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
COOL EXPOS CNTNRS W/H2O TO PVNT PRESS BUILDUP.IF LRG QTYS OF MATL
INVOLVED, EVAC AREA & FIGHT (SUPP DATA)
Unusual Fire/Explosion Hazard:DECOMPOSITION AND COMBUSTION PRODUCTS MAY
BE TOXIC. CLOSED CONTAINERS MAY VIOLENTLY RUPTURE UNDER FIRE
CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:SML SPILLS: ACTIVATE AVAIL EXHST VENT EQUIP IN
IMMED SPILL AREA.WIPE UP/ABSORB SPILLED MATL W/VERMICULITE/OTHER
SIMILAR MATL.WASH AREA W/SOAPY H*2O TO REMOVE RESIDUE. COLLECT
ABSORB MATL & H*2O RINSES IN APPROP CNTNRS. LRG SPILLS: LIMIT
ACESS (ING 6)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY LOCATION W/ADEQ
VENT. KEEP CNTNR TIGHTLY SEALED WHEN NOT IN USE. KEEP AWAY FROM
OPEN FLAMES & HEAT SOURCES.
Other Precautions:CONSULT THE PRODUCT TECHNICAL BULLETIN FOR DETAILED
STORAGE INFORMATION.
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:NEGLIGIBLE
Solubility in Water:INSOLUBLE
Appearance and Odor:OFF-WHITE LIQUID.
Percent Volatiles by Volume:NEG
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
INCOMPAT W/STRONG OXIDIZERS, ACIDS, BASES; UNCONTROLLED MIX W/AMINES,
ANHYDRIDES, MERCAPTANS, IMIDAZOLES MAY (SUPP DATA)
Stability Condition to Avoid:AVOID STORAGE IN OPEN CNTNRS,EXPOS TO OPEN
FLAME/UNCONTROLLED EXPOS TO HEAT, UNCONTROLLED MIX W/CURING
AGENTS(SUPP DATA)
Hazardous Decomposition Products:CO, CO*2,ALDEHYDES, ACIDS & OTHER ORG
SUBSTANCES MAY BE FORMED DURING COMBUST. PRLNGD EXPOS TO ELEVATED
TEMPS(SUPP DATA)
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH CURRENT FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT GENERALLY REQUIRED. IF DUST IS LIKELY TO BE
CREATED IN HANDLING, WEAR NIOSH/MSHA APPROVED DUST RESPIRATOR.
Ventilation:NOT GENERALLY REQUIRED.
Other Protective Equipment:NORMAL WORK CLOTHES.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM NITRATE, (SALTPETER)
Ingred Name:SODIUM(I) NITRATE (1:1)
Fraction by Wt: 5%
Ingred Name:AMMONIUM DIHYDROGEN PHOSPHATE; (MONOAMMONIUM PHOSPHATE)
Ingred Name:UREA
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: EYE CONTACT W/DRY MATERIAL OR
MATERIAL IN SOLUTION MAY BE SLIGHTLY TO MODERATLY IRRITATING. SKIN:
SLIGHT IRRITATION IS POSSIBLE UPON PROLONGED OR REPEATED CONTACT
W/SKIN. BLUE DYE MAY CAUSE TEMP ORARY STAINING OF SKIN. INGEST: IF
SWALLOWED IN LARGE AMOUNTS, MAY CAUSE NAUSEA, VOMITING & (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: DIARRHEA. SYMPTOMS OF NITRATE
POISONING ARE THEORETICALLY POSSIBLE BUT NOT EVIDENT IN ANIMALS
TESTED. INHAL: OVEREXPOSURE IS UNLIKELY. IF DUST IS INHALED IN
LARGE AMOUNTS, MAY BE IRRITATING TO UPPER RESPIRATORY TRACT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
OBTAIN MED ATTN. SKIN:WASH W/SOAP & WATER PROMPTLY TO REMOVE DYE &
PVNT POSS IRRIT. IF IRRIT DEVELOPS, OBTAIN MED ATTN. INGEST: INDUCE
VOMIT BY GIVING 2 GLASSES OF WATER TO DRINK & STICKING FINGER DOWN
THROAT. CALL PHYS. NEVER GIVE ANYTHING BY MOUTH TO AN UNCON PERSON.
INHAL: REMOVE TO FRESH AIR. IF SYMPS OF IRRIT DEVELOP, CONT PHYS.
* Fire Fighting Measures *
Extinguishing Media:IN CASE OF FIRE, SOAK (FLOOD) W/WATER.
Fire Fighting Procedures:NISOH/MSHA APPRVD SCBA & FULL PROT EQUIP.
AMMONIA GAS MAY BE REL AS A RSLT OF HEATING MONOAMMONIUM PHOSPHATE.
Unusual Fire/Explosion Hazard:PRODUCT CONTAINS POTASSIUM NITRATE AND
SODIUM NITRATE WHICH ARE OXIDIZERS IN THEIR PURE OR UNMIXED FORMS.
TREAT DRY PRODUCTS AS AN OXIDIZER IN FIRE SITUATIONS.
* Accidental Release Measures *
Spill Release Procedures:PVNT PROD FROM ENTERING DRINKING WATER
SUPPLIES/STREAMS. OBSERVE HANDLING PRECAUTIONS. SWEEP INTO DRY
CONTAINERS, RECYCLE OR REMOVE FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT W/EYES AND SKIN. KEEP
OUT OF REACH OF CHILDREN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Spec Gravity:SUPP DATA
pH:SUPDAT
Appearance and Odor:AQUA-BLUE POWDER W/SLIGHT YEASTY ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ALKALINE MATERIALS, CORROSIVE TO CAST IRON AND
ALUMINUM.
MONOAMMONIUM PHOSPHATE POLYMERIZES UPON HEATING, LIBERATING
AMMONIA.
Hazardous Decomposition Products:AMMONIA, POLYPHOSPHATE GLASS, NITROUS
OXIDES, CYANURIC ACID, CYANIC ACID, CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:ACCORDING TO US EPA WASTE OF THIS MATERIAL IS
NOT DEFINED AS HAZARDOUS. DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROT
AGAINST MATERIALS.
Ventilation:USE ONLY W/ADEQ VENT. AVOID BRTHG VAP & SPRAY MIST. AVOID
CONT W/SKIN & EYES. LOC EXHST: PREF. GENL EXHST: (SUPP DATA)
Other Protective Equipment:EYE WASH, SAFETY SHOWERS.
Work Hygienic Practices:KEEP WORK AREA CLEAN & FREE FROM SPILLS &
* Product Identification *
Product ID:ORANGE LATEX, LEAD FREE TRAFFIC LINE PAINT
Preparer's Name:NORMA HABEEB
* Composition/Information on Ingredients *
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL; (TEXANOL)(ESTER ALCOHOL)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: PROLONGED INHAL IN
CONFINED AREAS MAY LEAD TO MUCOUS MEMBRANE IRRITATION, DIZZINESS,
HEADACHE. SKIN: IRRITATION OF SKIN. EYE: IRRITATION OF EYES.
INGEST: AMTS INGESTED INCIDENTAL TO CONS UMER & INDUSTRIAL HANDLING
ARE NOT LIKELY TO CAUSE INJURY, HOWEVER, INGESTION OF LARGER AMTS
COULD CAUSE(EFTS OF OVEREXP
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: SERIOUS INJURY.
Medical Cond Aggravated by Exposure:NONE WHEN USED IN ACCORDANCE W/SAFE
HANDLING INSTRUCTIONS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. IF RESPIRATORY SYMPTOMS DEVELOP,
SEEK MED ATTN AT ONCE. SKIN: WASH OFF QUICKLY WITH PLENTY OF WATER,
THEN SOAP & WATER. REMOVE & WASH CONTAMINATED CLOTHING BEFORE
REUSE. EY E: FLUSH IMMEDIATELY W/LGE AMOUNTS OF WATER, ESPECIALLY
INGEST: OBTAIN MED TREATMENT IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, DRY CHEMICAL, WATER OR WATER FOG. USE ANY
CLASS B EXTINGUISHING AGENT.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
EVACUATE AREA OF UNPROTECTED PERSONNEL. WEAR PROTECTIVE CLOTHING.
EVAC AREA OF UNPROT PERSONNEL.
Unusual Fire/Explosion Hazard:WILL NOT BURN, CLOSED CONTAINERS MAY
BURST IF EXPOSED TO EXTREME HEAT. WATER MAY BE USED TO COOL &
PROTECT EXPOSED CONTAINERS.
* Accidental Release Measures *
Spill Release Procedures:COMPLY W/ALL APPLICABLE HEALTH & ENVIRONMENTAL
REGULATIONS. VENT AREA. SPILLS MAY BE COLLECTED W/ABSORBENT MATLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
FROM FREEZING. STORE CONTAINERS W/LIDS TIGHTLY CLOSED AND
APPROPRIATELY LABELED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
LEAKS. ALWAYS WASH HANDS THORO W/SOAP & H*2O BEFORE HNDLG FOOD,
DRINK/SMOKING.
Supplemental Safety and Health
VENT: ACCEPTABLE IF EXPOSURE TO MATERIALS IS MAINTAINED BELOW
APPLICABLE EXPOSURE LIMITS.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
pH:9.0
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INFINITE
Appearance and Odor:ORANGE LIQUID W/SLIGHT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS &/HYDROFLUORIC ACID.
Stability Condition to Avoid:ELEVATED TEMPERATURES, CONTACT W/OXIDIZING
AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE & CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE & FEDERAL
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | gloves_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A PROPERLY FITTED NIOSH OR MSHA APPROVED AIR
EQUIVALENT.
Ventilation:GENERAL DILUTION. LOCAL EXHAUST SHOULD BE PROVIDED.
Other Protective Equipment:WEAR LOOSE FITTING, LONG SLEEVED SHIRT, LONG
PANTS, SAFETY SHOWERS & EYE WASH FOUNTAINS.
Work Hygienic Practices:WASH CLOTHES SEPARATELY & WIPE OUT WASHER, TO
PREVENT FIBERS FROM GETTING ON OTHER CLOTHES. WASH HANDS
THOROUGHLY.
Supplemental Safety and Health
APPEAR CON'T: SOME PRODUCTS HAVE A VINYL, KRAFT PAPER, FOIL OR
POLYPROPYLENE FACING.
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: UPPER RESPIRATORY TRACT,
MOUTH, NOSE, & THROAT IRRITATION. SKIN: ITCHING & TEMPORARY
MECHANICAL IRRITATION. EYES: TEMPORARY MECHANICAL IRRITATION.
INGESTION: DIGESTIVE TRACT TEMPORARY MECH ANICAL IRRITATION.
Explanation of Carcinogenicity:NONE
Medical Cond Aggravated by Exposure:CHRONIC RESPIRATORY OR SKIN
CONDITIONS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH W/MILD SOAP &
RUNNING WATER. USE A WASHCLOTH TO HELP REMOVE FIBERS. TO AVOID
FURTHER IRRITATION DO NOT RUB OR SCRATCH IRRITATION AREAS. RUBBING
OR SCRATCHIN G MAY FORCE FIBERS INTO SKIN. USE OF BARRIER CREAM CAN
MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER, FOAM, DRY CHEMICAL
Fire Fighting Procedures:IN A SUSTAINED FIRE, SELF-CONTAINED BREATHING
APPARATUS SHOULD BE WORN.
Unusual Fire/Explosion Hazard:VINYL FACED IN FIRE CONDITIONS MAY GIVE
OFF HYDROGEN CHLORIDE, A HIGHLY IRRITATING & TOXIC GAS. EVACUTE THE
BUILDING IMMEDIATELY.
* Accidental Release Measures *
Spill Release Procedures:USE VACUUM EQUIPMENT TO CLEAN DUSTS & FIBERS.
AVOID SWEEPING OR USING COMPRESSED AIR AS THESE TECHNIQUES
RESUSPEND DUSTS & FIBERS INTO THE AIR.
*Handling and Storage *
Handling and Storage Precautions:INSULATION SHOULD BE STORED IN A DRY
PLACE. FACED MATERIAL SHOULD BE STORED WELL AWAY FROM SOURCES OF
IGNITION.
Other Precautions:AVOID DUST & FIBERS.
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE
Appearance and Odor:PINK, YELLOW, OR TAN W/FAINT RESIN ODOR. SEE SUPP
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO, CO2, AMMONIA, WATER, & HYDROGEN
CHLORIDE. VINYL FACED PRODUCTS WILL RELEASE HYDROGEN CHLORIDE IN A
FIRE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS. THE PRIMARY METHOD OF DISPOSAL IS IN A MUNICIPAL
OR INDUSTRIAL LANDFILL.
| 1 | gloves_mandatory |
Subsets and Splits
No saved queries yet
Save your SQL queries to embed, download, and access them later. Queries will appear here once saved.