text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:STAINLESS STEEL CLEANER, & POLISH (AEROSOL).
Preparer's Name:THOMAS J. MITCHELL
CAGE:23212
CAGE:23212
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 5-10%
Other REC Limits:1800MG/M3
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9495
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE IRRIT.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH EYE W/PLENTY OF WATER FOR >15
MINUTES, REMOVE CONTACT LENSES. IF IRRIT PERSISTS, SEEK MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<32F,<0C
Extinguishing Media:WATER FOG, DRY CHEMICAL, CO2.
Fire Fighting Procedures:USE EQUIPMENT OR SHIELDING REQUIRED TO PROTECT
PERSONNEL AGAINST BURSTING RUPTURING, OR VENTING CONTAINERS.
Unusual Fire/Explosion Hazard:AT TEMPS (>54C/130F) CONTAINERS MAY VENT,
RUPTURE OR BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE W/WATER & FLUSH INTO SANITARY SEWER
SYSTEM.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS UNDER PRESSURE, DO NOT USE
NEAR FIRE, SPARKS, OR FLAME. DO NOT STORE WHERE TEMPERATURES COULD
EXCEED 125F.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT FOR MOST
CONDITIONS. LOCAL EXHAUST MAY BE NECESSARY FOR SOME OPERATIONS.
Other Protective Equipment:NONE REQUIRED.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NA
Spec Gravity:0.97
pH:8.8
Evaporation Rate & Reference:<1.0
Solubility in Water:COMPLETE.
Appearance and Odor:CREAMY SPRAYED FILM, LEMON FRAGRANCE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Hazardous Decomposition Products:CO, CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE OR PUNCTURE AEROSOL CONTAINER.
DISPOSE OF IN ACCORDANCE W/STATE & LOCAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:120 0609,EKTAPRINT R-1000 STOP BATH
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID (SARA III)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 72.5%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER,25-30% (CAS #7732-18-5)
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 27.5%
===================== Hazards Identification =====================
Effects of Overexposure:EYES/SKIN: LIQUID BURNS;VAPOR IRRITATES EYES &
UPPER RESPIRATORY TRACT.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: IMMEDIATELY FLUSH WITH PLENTY OF WATER. GET
MEDICAL ATTENTION FOR EYES INJURY; INHALATION: REMOVE FROM
EXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CO*2,DRY CHEM,FOAM
Fire Fighting Procedures:FRESH AIR MASK
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:GATHER & DILUTE IN WATER. FLUSH TO DESIGNATE
DISPOSAL LINES WITH COPIOUS AMOUNTS OF WATER.PRE-FLUSH LINES WITH
COPIOUS AMOUNTS OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DONOT STORE NEAR ALKALIS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED ORGANIC ACID VAPOR IF INADEQUATE
VENTILATION
Ventilation:LOCAL & MECHANICAL EXHAUST.
Other Protective Equipment:AS NECESSARY TO PREVENT SKIN CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:> 220 F
Vapor Pres:17.
Vapor Density:1.70
Spec Gravity:1.08
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,COLORLESS SOLUTION;VINEGAR ODOR.
Percent Volatiles by Volume:90.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIS(BASES),FLAMMABLEES, & OXIDIZERS
Stability Condition to Avoid:FIRE SOURCES
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:REVIEW FEDERAL,STATE, AND LOCAL REGULATIONS
CONCERNING HEALTH & POLLUTION PRIOR TO DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LEAD/ACID STORAGE BATTERY - HYBRID
CAGE:20038
CAGE:64812
CAGE:0FGN2
CAGE:20038
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA III) *
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: >60%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ANTIMONY (SARA III) *
CAS:7440-36-0
RTECS #:CC4025000
Fraction by Wt: >2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3 *
ACGIH TLV:0.5 MG SB/M3; 9192 *
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ARSENIC (SARA III) *
CAS:7440-38-2
RTECS #:CG0525000
Fraction by Wt: <0.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.01 MG/M3 (AS) *
ACGIH TLV:0.2 MG/M3; 9192 *
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CALCIUM, METAL
CAS:7440-70-2
RTECS #:EV8040000
Fraction by Wt: <0.2%
Other REC Limits:NONE SPECIFIED
Ingred Name:SULFURIC ACID (SARA III) *
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 10-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3 *
ACGIH TLV:1 MG/M3; 9192 *
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POLYPROPYLENE
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:INHALATION OF ACID VAPORS MAY
CAUSE SEVERE IRRITATION OR BURNS OF THE RESPIRATORY SYSTEM,
PULMONARY EDEMA, OR LUNG INFLAMMATION. MAY CAUSE SEVERE BURNS TO
SKIN OR EYES. INGESTION MAY CAUSE SEVER E BURNS TO MOUTH, THROAT,
AND STOMACH. MAY AFFECT KIDNEY FUNCTION. CHRONIC:MAY DAMAGE
LUNGS,TEETH EROSION.
Explanation of Carcinogenicity:ARSENIC (IN ELECTRODES) IS LISTED BY
IARC, NTP, & OSHA AS A CARCINOGEN.
Effects of Overexposure:ACID:SEVERE IRRITATION OR BURNS TO EYES, NOSE
AND THROAT. PULMONARY EDEMA, BRONICAL EMPHYSEMA, CONJUNCTIVITIS,
STOMATITIS, DENTAL EROSION, NAUSEA AND VOMITING. LEAD:STOMACH
CRAMPS, ANEMIA AND NERVE DA MAGE.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE RESPIRATORY TRACT MAY
BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN:
REMOV E CONTAMINATED CLOTHING. WASH WITH PLENTY OF WATER FOR 15
MINUTES. GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE VOMITING. GIVE
NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Lower Limits:4.1( FOR H2)
Upper Limits:74.2(FOR H2)
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:IF CHARGING, SHUT OFF POWER. WEAR
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:WILL GENERATE HYDROGEN ON OVERCHARGE. MAY
EXPLODE IN FIRE AND PRODUCE HAZARDOUS FUMES AND OXIDE OF SULFUR
GASES.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE CLOTHING. STOP LEAK IF YOU CAN
DO SO WITHOUT RISK. DO NOT USE WATER. NEUTRALIZE SPILL AND/OR
WASHINGS WITH SODA ASH OR LIME. WITH CLEAN SHOVEL, PLACE MATERIAL
INTO CLEAN, DRY CONTAINER .
Neutralizing Agent:J.T.BAKER'S NEUTRASORB (R) OR TEAM 'LOW NA+' ACID
NEUTRALIZERS ARE RECOMMENDED.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN CORROSION-PROOF AREA. KEEP CONTAINERS OUT OF SUN AND AWAY FROM
HEAT. ISOLATE FROM INCOMPATIBLE MATERIALS.
Other Precautions:DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. DO NOT
BREATHE VAPOR. KEEP IN TIGHTLY CLOSED CONTAINER. LOOSEN CLOSURE
CAUTIOUSLY. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER
HANDLING. IN CASE OF SPILL NEUTRALIZE WITH SODA ASH OR LIME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION EXCEEDS TLV, A NIOSH
APPROVED SELF-CONTAINED BREATHING APPARATUS IS RECOMMENDED.
Ventilation:USE MECHANICAL (GENERAL) OR LOCAL EXHAUST VENTILATION TO
MEET TLV REQUIREMENTS.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:=95.C, 203.F
Vapor Pres:10
Vapor Density:>1
Spec Gravity:1.2-1.3
pH:<2.0
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:100%
Appearance and Odor:LEAD/ACID BATTERY, POLYPROPYLENE CASING.
ELECTROLYTE IS CLEAR LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, COMBUSTIBLES, ORGANIC MATERIAL, PROLONGED
OVERCHARGE.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES .
Hazardous Decomposition Products:OXIDES OF SULFUR, HYDROGEN GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EDTA, DISODIUM SALT 247
Preparer's Name:LM
CAGE:0A5V1
CAGE:0A5V1
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENEDIAMINETETRAACETIC ACID, DISODIUM SALT
CAS:139-33-3
RTECS #:AH4375000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL) 2000MG/KG(RAT)
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DUST MAY BE IRRITATING TO EYES AND
NASAL PASSAGES. TOXICITY LOW. NOT CONSIDERED A HAZARDOUS MATERIAL.
Explanation of Carcinogenicity:NO EVIDENCE OF CARCINOGENICITY.
Effects of Overexposure:EYE, SKIN & RESPIRATORY TRACT IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:WASH SKIN AND EYES THOROUGHLY WITH WATER AFTER CONTACT.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE CONDITIONS.
Fire Fighting Procedures:USE WATER TO COOL FIRE EXPOSED CONTAINERS. USE
PROTECTIVE CLOTHING. USE SELF-CONTAINED BREATHING APPARATUS. REMOVE
CONTAINERS FROM FIRE AREA IF POSSIBLE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AND DISCARD TO INCINERATOR OR TO
SOLID WASTE. SMALL AMOUNTS TO SANITARY DRAIN.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN A COOL, DRY AREA.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED DUST RESPIRATOR.
APPROPRIATE RESPIRATORS MAY BE A FULL FACEPIECE OR A HALF MASK
AIR-PURIFYING CARTRIDGE RESPIRATOR WITH PARTICULATE FILTERS, A SCBA
IN THE PRESSURE DEMAND MODE OR A SUPPLIED-AIR RESPIRATOR.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:NONE
Work Hygienic Practices:WASH SKIN AND EYES THOROUGHLY WITH WATER AFTER
CONTACT.
Supplemental Safety and Health
NAVY HAS FORWARDED THIS MSDS TO DLA FOR ENTRY INTO THE HMIS. A REVIEW
OF THE TECHNICAL DATA FOR THIS NSN INDICATES THAT THE NAVY MAY HAVE
MISIDENTIFIED THE NSN AND THAT THIS PRODUCT MAY NOT CONFORM TO THE
ITEM DESCRIPTION AND/OR SPECIFICATION.
================== Physical/Chemical Properties ==================
HCC:C3
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:=252.2C, 486.F
Decomp Temp:=250.C, 482.F
Vapor Pres:NEGLIGIBLE
Vapor Density:11.6
Spec Gravity:1.57
pH:4-6
Solubility in Water:SLIGHT
Appearance and Odor:HYGROSCOPIC, WHITE CRYSTALLINE POWDER
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:OCLANSORB,SPILCL
Kit Part:Y
CAGE:0TT89
CAGE:0TT89
============= Composition/Information on Ingredients =============
Ingred Name:PEAT
Fraction by Wt: >95%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SOIL
Fraction by Wt: <5%
Other REC Limits:10 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- EYE:MAY CAUSE IRRITATION. INHALATION:MAY BE
SLIGHTLY IRRITATING AT VERY HIGH CONCENTRATIONS. SKIN/INGESTION:NO
KNOWN HEALTH HAZARD. CHRONIC- UN KNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. EYES:FLUSH WITH PLENTY OF WATER, HOLDING EYELIDS OPEN.
SKIN:WASH WITH SOAP & WATER. ORAL:SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL.
USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SHOVEL OR SWEEP UP SPILL. AVOID CREATING DUST.
PLACE IN APPROPRIATE CONTAINER FOR REUSE OR DISPOSAL. VENTILATE
AREA AND WASH SPILL SITE WITH DETERGENT AND WATER.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY PLACE. KEEP CONTAINER
TIGHTLY CLOSED. USE IN VENTILATED AREA.
Other Precautions:DO NOT RAISE DUST. AVOID CONTACT WITH EYES, SKIN OR
CLOTHING. AVOID INHALATION OF DUST. WASH THOROUGHLY AFTER HANDLING
MATERIAL. KEEP OUT OF REACH OF SMALL CHILDREN. DO NOT INGEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF AIRBORNE
CONCENTRATION IS HIGH, WEAR A NIOSH-APPROVED DUST RESPIRATOR OR
DUST MASK.
Ventilation:GOOD GENERAL VENTILATION IS SUFFICIENT FOR MOST CONDITIONS
(10 ROOM VOLUMES PER HOUR).
Other Protective Equipment:EYE BATH, SAFETY SHOWER, WASHING FACILITIES
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
KEY1:N1. THIS PRODUCT IS A KIT CONSISTING OF OCLANSORB (PNI A),
SORB-SOX (PNI B), SLICK WICK (SW) ABSORBENT SHEETS (PNI C) AND TWO
BIT (PNI D).
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:INSOLUBLE;WILL REPEL
Appearance and Odor:BROWN POWDER - ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:MOISTURE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:UNUSED MATERIAL IS NOT A HAZARDOUS WASTE. THE
POWDER MAY BE BURIED IN A SANITARY LANDFILL OR INCINERATED. ENSURE
COMPLIANCE WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EPOXY COMP-B SRCRO4 ACFT PRIMER 44GN024 CAT
Kit Part:Y
CAGE:DO188
CAGE:33461
CAGE:DO188
============= Composition/Information on Ingredients =============
Ingred Name:SEC-BUTYL ALCOHOL
(VAPOR PRESSURE 12.5 MM HG )
CAS:78-92-2
Fraction by Wt: 50%.
OSHA PEL:150 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: < 5%.
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:AMINO SOLANE ESTER
Fraction by Wt: < 5%.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:VAPORS IRR TO EYES, NOSE, THROAT.
INHALE MAY CAUSE HEADACHE, DIFF BREATH & LOSS OF CONSC. CHRONIC:
PROLONGED CONTACT DRY & CRACKING OF SKIN, DEFATT ACTION.
SKINSENSITIZATION, ASTHMA OR ALLERGIC RESPON SES. DELAYED EFFECTS
INVOLVING BLOOD,GASTROINTESTINAL, NERVOUS & REPRODUCTIVE SYSTEMS.
Effects of Overexposure:INHALE: IRRI OF RESPIRATORY TRACT, ACUTE
NERVOUS SYS DEPRESSION CHAR; DEPRESSIONHEADACHE, DIZZ, STAGG GAIT,
CONFUSION, UNCONSC OR COMA. SKIN: IRRI, SWELL, RED, RASH, ABSORB
MOD IRRI, DRY, DEFATT. EYE: IRRI. INGEST: IRRI, POSS CORROSIVE
ACTION IN MOUTH, STOMACH TISSUE & DIGESTIVE TRACT. VOMIT
ASPIRATION-CHEM PNEUMONITIS
Medical Cond Aggravated by Exposure:ASTHMA & ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMITITS
======================= First Aid Measures =======================
First Aid:INHALE: REMOVE TO FRESH AIR. ASTHMATIC TY SYMPTOMS MAY
DEVELOP. GET MED ATTN. SKIN: REMOVE CONTAM CLOTHS. WASH AFFECTED
AREAS W/SOAP & WATER. LAUNDER CLOTHINGBEFORE RE-USE. EYES: FLUSH
W/CLEAN WATER 15 MIN. LIFTING LIDS. OBTAIN MED ATTN.INGEST: DO NOT
INDUCE VOMIT. DO NOT GIVE ANYTHING TO AN UNCONSC PERSON. OBTAIN
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:45 F/ 7.22 C
Lower Limits:1.
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:FULL FIRE FIGHT EQUIP W/ SELF-CONTAINED BREATH
APPARAUS & FULL PROTECTIVE CLOTH.WATER TO COOL CLOSED CONTAINERS TO
PREVENT PRESSURE BUILDUP/AUTO IGNITION/EXPLOS
Unusual Fire/Explosion Hazard:KEEP CONT TIGHTLY CLOSED. ISOLATE FROM
HEAT, SPARKS, ELEC EQUIP & OPEN FLAME. CLOSED CONT MAY EXPLODE FROM
EXTREME HEAT. OVEREXP TO DECOMP MAY BE HEALTH HAZARD
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONS. REMOVE ALL
SOURCES OF IGNITION. VENTILATE AREA. CONTAIN & REMOVEWITH INERT
ABSORBENT & NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN BLDGS DESIGNED TO COMPLY WITH
OSHA. AVOIDSTORING NEAR HIGH TEMP, FIRE, OPEN FLAMES, &
SPARKSOURCES. STORE IN TIGHTLY CLOSED CONTAINERS.
Other Precautions:STORE IN VENTILATED AREAS. KEEP CONTAIN TIGHT &
UPRIGHT TO PREVENT LEAKAGE. PRE-VENT EXPOSURE MAY CAUSE AN ALLERGIC
REACTION. AVOID CONTACT W/SKIN & EYES. DON'TTAKE INTERNALLY. DON'T
HANDLE UNTIL SAFE TY PRECAUTIONS HAVE BEEN READ/UNDERSTOOD
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR THAT IS APPROVED FOR ORGANIC VAPOR
ENVIRONMENT AIR PURIFYING OR FRESHAIR SUPPLIED) IS NECESSARY.
OBSERVE OSHA REG. FOR RESPIRATOR USE. VENT SHOULDBE PROVIDED TO
KEEP EXPOSURE LEVELS BELO W THE OSHA PERMISSIBLE LIMITS.
Ventilation:SUFFICIENT TO KEEP THE AIRBORNE CONCENTRATE OF SOLVENT
VAPORBELOW RESPECTIVE TLV. REMOVE ALL IGNITION SOURCES
Other Protective Equipment:USE LONG SLEEVE & LONG LEG CLOTHING. REMOVE
& WASH CONTAMIN-ATED CLOTHING BEFORE RE-USE.
Supplemental Safety and Health
THIS PRODUCT MAY CONTAIN TOXIC CHEMICALS SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND
AMENDMENTS & REAUTHORIZTION ACT OF 1986 & 40 CFR PART 372.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:211-498 F
Vapor Density:> AIR
Evaporation Rate & Reference:0.68 X N-BUTYL ACETATE
Appearance and Odor:AMBER LIQUID WITH SOLVENT ODOR
Percent Volatiles by Volume:56.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS AND STRONG LEWIS OR MINERAL ACIDS
Stability Condition to Avoid:HIGH TEMP, SPARKS, OR OPEN FLAMES. AVOID
UNCONTROLLED REAC- TIONS WITH AMINES
Hazardous Decomposition Products:HIGH HEAT/TEMP; CARBON
MONOXIDE/DIOXIDE, OXIDES OF NITROGEN.ALDEHYDES, ACIDS FORMED DURING
COMBUST. CHROMIUM OXIDES BURN
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH FEDERAL, STATE & LOCAL
ENVIRON CONTROL REG. EMPTY CONTAINERS MUST BE HANDLED WITHCARE, DUE
TO PRODUCT RESIDUE & FLAMMABLE VAPOR. DO NOT INCINERATE CLOSED
CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NOX RUST 207 (FORMERLY NOX RUST X 425)
Preparer's Name:J. KUKSUK
CAGE:7X108
CAGE:7X108
CAGE:6X798
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA, MEDIUM ALIPHATIC (TOTAL PERCENTAGE OF INGREDIENTS
1, 2, AND 3 : 38-43)
CAS:64742-88-7
Fraction by Wt: SEE ING
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:HYDROTREATED LIGHT PETROLEUM DISTILLATE
CAS:64742-47-8
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MISTS
ACGIH TLV:5 MG/M3 AS OIL MISTS
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9394
Ingred Name:LEAD SOAP OF OXIDIZED PETROLEUM FRACTION
CAS:67674-14-0
Fraction by Wt: 30 - 35%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 MICROGRAMS/M3.
ACGIH TLV:0.15 MG/M3 AS PB.
Ingred Name:SOLVENT REFINED HEAVY NAPHTHENIC DISTILLATE, PETROLEUM
(TOTAL PERCENTAGE OF INGREDIENTS 5 AND/OR 6: 15-20)
CAS:64741-96-4
RTECS #:PY8040000
Fraction by Wt: SEE # 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MISTS
ACGIH TLV:5 MG/M3 AS OIL MISTS
Ingred Name:HYDROTREATED HEAVY NAPHTHENIC DISTILLATE,
PETROLEUM/LUBRICATING OIL BASE STOCK
CAS:64742-52-5
RTECS #:PY8035000
Fraction by Wt: SEE # 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 OIL MIST
ACGIH TLV:5 MG/M3 OIL MIST
Ingred Name:ASPHALT (PETROLEUM)
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: 1 - 3%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 MG/M3; (FUME);9394
Ingred Name:CALCIUM HYDROXIDE
CAS:1305-62-0
RTECS #:EW2800000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:5 MG/M3; 9394
Ingred Name:VOLATILE ORGANIC COMPOUNDS (2.3 LBS/GAL)
RTECS #:9999999VO
Other REC Limits:NOT RELEVENT
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, LUNG, CNS.
ACUTE- MAY CAUSE EYE, SKIN IRRITATION. PROLONGED SKIN CONTACT MAY
CAUSE DERMATITIS/OIL ACNE. BREATHING MIST MAY CAUSE
DIZINESS/PULMONARY IRRITATION. INGESTION NOT L IKELY. CHRONIC-
COULD CAUSE LEAD POISONING. MAY DAMAGE RED BLOOD CELL FORMATION,
KIDNEY & NERVOUS SYSTEM. DERMATITIS.
Explanation of Carcinogenicity:CONTAINS LEAD. ASPHALT SOLUTIONS ARE
CONSIDERED TO BE ANIMAL CARCINOGENS BY IARC.
Effects of Overexposure:EYE, SKIN, RESPIRATORY TRACT IRRITATION, DRYING
OF SKIN, HEADACHE, DIZZINESS, NAUSEA, INCOORDINATION, LOSS OF
APPETITE, CONSTIPATION, ANEMIA, FATIGUE, DISTURBANCE OF SLEEP,
COLIC, NEURITIS, METALLIC T ASTE IN MOUTH, ANXIETY, HYPERTENSION
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY AND SKIN
DISEASES MAY BE AGGRAVATED.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN:REMOVE
CONTAMINATED CLOTHING. WASH SKIN WITH SOAP & WATER. EYE:FLUSH WITH
WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN. INHALED:REMOVE TO FRESH
AIR. PROVI DE OXYGEN/CPR IF NEEDED. ORAL:DO NOT INDUCE VOMITING. IF
VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT
ASPIRATION OF LIQUID INTO THE LUNGS. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:105F,41C
Lower Limits:0.6
Upper Limits:7.0
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CO2. DO NOT
USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. COOL FIRE-EXPOSED CONTAINERS
WITH WATER SPRAY. ISOLATE AREA AND DENY ENTRY.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND MAY TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN SPILL. PICK UP SPILL WITH
NON-FLAMMABLE ABSORBENT MATERIAL SUCH AS SAND. PLACE IN CONTAINER
FOR DISPOSAL. PREVENT LIQU ID FROM ENTERING SEWERS, WATERWAYS OR
LOW AREAS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED AREA
AWAY FROM SOURCES OF IGNITION AND INCOMPATIBLES. EMPTY CONTAINERS
CAN CONTAIN EXPLOSIVE VAPORS.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE. DO NOT CUT, WELD,
DRILL SUCH CONTAINERS. HYDROGEN SULFIDE MAY ACCUMULATE IN STORAGE
TANKS. AVOID BREATHING VAPORS. WASH THOROUGHLY AFTER HANDLING.
DISCARD OIL-SOAKEDLEATHER MATERIALS IF CANNOT BE CLEANED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKING IN CONFINED AREAS, IF EXCESSIVE
MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES EXCEED RECOMMENDED
PERMISSIBLE EXPOSURE LIMITS (PEL), WEAR NIOSH-APPROVED RESPIRATORY
PROTECTION (REFER TO 29 CFR 1910.134).
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW PEL(S).
Other Protective Equipment:IF EXCESSIVE SPLASHING IS EXPECTED, USE A
RUBBER APRON AND FACE SHIELD. PROVIDE EYEWASH STATION AND EMERGENCY
SHOWERS.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>300F,>149C
Melt/Freeze Pt:M.P/F.P Text:NOT KNOWN
Vapor Pres:3.4 @ 68F
Vapor Density:>1
Spec Gravity:0.896
Viscosity:NOT KNOWN
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK LIQUID, PETROLEUM SOLVENT ODOR
Percent Volatiles by Volume:36
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS
Stability Condition to Avoid:EXCESSIVE HEAT, OPEN FLAMES
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE, CARBON
DIOXIDE, OXIDES OF SULFUR, MISCELLANOUS HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. ALL RESPONSE ACTIVITES MUST BE COMPLY WITH
HAZPOWER (29 CFR 1910.120). IF PERMITTED, INCINERATION MAY BE
PRACTICED. CONSIDER REC YCLING SOLVENT.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:E 15,ASBESTOS
Kit Part:Y
CAGE:2J502
CAGE:23040
CAGE:2J502
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS (FRIABLE)(SARA III)
CAS:1332-21-4
RTECS #:CI6425000
Fraction by Wt: > 60%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1001
ACGIH TLV:0.2 - 2 FIBERS/CC
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE & CHRONIC-HARMFUL IF
INHALED/SWALLOWED.MAY CAUSE IRRITATION OF EYES,SKIN & RESPIRATORY
TRACT.PROLONGED/REPEATED BREATHING OF ASBESTOS PARTICLES CAN
PRODUCE CHRONIC LUNG DISEASE(ASBESTOSIS),PLEUR AL PLAQUE &
CANCER.SYMPTOMS MAY TAKE YEARS TO DEVELOP.SMOKERS ARE AT A GREATER
RISK OF DEVELOPING CANCER FROM ASBESTOS.
Explanation of Carcinogenicity:ASBESTOS IS REGULATED BY OSHA AS A
CARCINOGEN.
Effects of Overexposure:HARMFUL IF INHALED/SWALLOWED. MAY CAUSE
IRRITATION OF EYES, SKIN & RESPIRATORY TRACT. PROLONGED/REPEATED
BREATHING OF ASBESTOS PARTICLES CAN PRODUCE CHRONIC LUNG DISEASE
(ASBESTOSIS), PLEURAL PLAQUE & CANCER. SYMPTOMS MAY TAKE YEARS TO
DEVELOP. SMOKERS ARE AT A GREATER RISK OF DEVELOPING CANCER FROM
ASBESTOS.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING
RESPIRATORY SYSTEMS DISORDERS MAY BE AGGRAVATED BY THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:SEEK MEDICAL ATTENTION IF SYMPTOMS DEVELOP. EYES:GENTLY RINSE
WITH WATER FOR 15 MINUTES WHILE KEEPING EYELIDS OPEN. SKIN:WASH
FREQUENTLY WITH SOAP AND WATER. INHALATION:REMOVE TO FRESH AIR.
INGESTION: GET IMMEDIATE MEDICAL ATTENTION OR ADVICE.
===================== Fire Fighting Measures =====================
Flash Point:NON FLAMMABLE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS OPERATED IN THE
POSITIVE PRESSURE MODE TO PREVENT INHALATION OF FIBERS.
Unusual Fire/Explosion Hazard:ASBESTOS FIBERS MAY BECOME AIRBORNE
DURING FIRE FIGHTING ACTIVITIES.
================== Accidental Release Measures ==================
Spill Release Procedures:TREAT DUST AS FREE ASBESTOS. DO NOT DRY SWEEP
OR USE COMPRESSED AIR. WET METHOD SHOULD BE USED FOR EXTRACTION OF
DUST AND DEBRIS. HIGH EFFICIENCY PARTICULATE APPARATUS (HEPA)
VACUUMS SHOULD BE USED. D O NOT ALLOW THIS MATERIAL TO ENTER SEWERS
ETC...
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE- DO NOT STIR UP THE DUST. THIS
PRODUCT FOR USE BY QUALIFIED PERSONNEL ONLY.
Other Precautions:USE IN WELL VENTILATED AREA. AVOID BREATHING DUST OR
FIBERS. MINIMIZE CONTACT WITH SKIN. AVOID CONTACT WITH EYES. DO NOT
RAISE DUST. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
DRINKING. KEEP AWAY FROM REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED HIGH EFFICIENCY FIBERS/FUMES
RESPIRATOR WHEN AIRBORNE FIBER CONCENTRATIONS EXCEED THE PEL.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV. CHECK LOCAL REGULATIONS
FOR EMISSION STANDARDS.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER, WORK
CLOTHING AND APRON AS REQUIRED. DO NOT WEAR CONTACT LENSES
Work Hygienic Practices:DON'T TAKE PROTECTIVE GEAR/CLOTHING HOME IF
EXPOSED TO DUST. DON'T SHAKE. DON'T EAT IN AREA WHERE ASBESTOS/DUST
PRESENT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T7
Spec Gravity:3.350
Appearance and Odor:WHITE SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:FIRE, EXTREME HEAT
Hazardous Decomposition Products:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE SHOULD BE CONTAINED IN IMPERMEABLE BAGS,
LABELED AND DISPOSED IN ACCORDANCE WITH ALL LOCAL, STATE AND
FEDERAL REGULATIONS. REPORTABLE QUANTITY FOR ASBESTOS IS 1 POUND.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LIQUID ELECTRICAL TAPE, RED 84155
Preparer's Name:JEFF TIEGER
CAGE:0GR42
CAGE:0GR42
============= Composition/Information on Ingredients =============
Ingred Name:7-OXABICYCLO(4.1.0)HEPTANE-3-CARBOXYLIC ACID,
7-OXABICYCLO(4.1.0)HEPT-3-YLMETHYL ESTER; (EPOXY CYCLOHEXYL (ING 2)
CAS:2386-87-0
RTECS #:RN7750000
Fraction by Wt: 4-6%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 1: METHYL CARBOXYLATE)
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DIETHYLENE GLYCOL, DIBENZOATE
CAS:120-55-8
RTECS #:ID6650000
Fraction by Wt: 6-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VINYL CHLORIDE/VINYL ACETATE COPOLYMER; (VINYL CHLORIDE)
CAS:9003-22-9
RTECS #:AK0950000
Fraction by Wt: 22-24%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TOLUENE; (METHYL BENZENE) (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 12-14%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHANE, DICHLORO-; (DICHLOROMETHANE) (SARA 313) (CERCLA)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 12-14%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-BUTANONE (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 36-38%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM; 300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (MAGNESIUM
SILICATE)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 2.9%
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 1.2%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:STYRENE ACRYL COPOLYMER; (STYRENE-ACRYLATE COPOLYMER)
CAS:68240-06-2
Fraction by Wt: 0.7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYESTER; (MODIFIED POLYESTER)
Fraction by Wt: 0.1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT: HEAT. VAPS ARE HVR/AIR & MAY TRAVEL ALONG GROUND,
COLLECT IN LOW AREAS/MAY IGNITE AT DISTANT LOCATION. (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:DO NOT WELD ON/NEAR CNTNR EVEN IF EMPTY. IF MATL
EXPOS TO EXTREME HEAT,AS IN FIRE, IT MAY POLYM & RUPTURE(ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: CLSD CNTNR. DECOMP BY BURN IN OPEN FLAME MAY YIELD
TOX HCL GAS & COMBUST BY-PRODS. WATER & FOAM MAY CAUSE FROTH.
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN: ANTIC TO BE CARCIN. CARBON BLACK: IARC
MONOGRAPHS ON EVAL OF CARCIN RISK OF CHEMS TO MAN, (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: VOL 65, PG 24-27, 1995:GROUP 2B.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:LIMS MAY CAUSE NERVOUS SYS DEPRESS W/DIZZ,
UNCON, LIVER & KIDNEY DMG. INTENTIONAL MISUSE MAY BE (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: HARMFUL/FATAL. RESP:DIZZ, HDCH,NAUS, ASPHY. IF PROD
HEATED POSS MUC MEMB & UPPER RESP IRRIT. INGEST: (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:NAUS, VOMIT & DIARR. ASPIR INTO LUNGS CAN CAUSE POSS
FATAL CHEM PNEUM. MOD TOX. CHRONIC:OVEREXP TO SOLVS (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: HAS BEEN ASSOC W/PERM BRAIN & NERVOUS SYSTEM
DAMAGE. CONTACT NEHC FOR MORE SPECIFIC INFO .
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: IMMED. DO NOT INDUCE VOMIT. KEEP WARM &
QUIET. GET MED ATTN. CONTACT NEHC FOR MORE SPECIFIC INFO .
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR: PROTECT FROM HEAT & FLAME. STORE DRUM OUT OF
INTENSE SUNLIGHT & AWAY FROM HEAT. KEEP CNTNRS TIGHTLY CLSD.
RTECS #:9999999ZZ
Ingred Name:OTHER PRECS:OF HEATED VAPS/SPRAY MISTS. KEEP AWAY FROM
HEAT/OPEN FLAME. CAUSES EYE DMG. DO NOT GET IN EYES, ON (ING 25)
RTECS #:9999999ZZ
Ingred Name:ING 24: SKIN OR ON CLTHG. USE W/ADEQ VENT. NO
SMOKING/EATING IN HNDLG AREAS. CNTCT NEHC FOR MORE SPECIFIC INFO .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CHLOROCARBON MATLS HAVE PRDCED SENSIT
OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE SIMILAR
EFT IN HUMANS. ADRENOMIMETICS (EG, EPINEPHRINE) MAY BE
CONTRA-INDICATED EXCEPT FOR LIFE-SUSTAININ G USES IN HUMANS
ACUTELY/CHRONICALLY EXPOS TO CHLOROCARBONS . EYE:TEARING, REDNESS &
DISCOMFORT. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE:IARC MONOGRAPHS,
SUPP, VOL 7, PG 194, 1987:GROUP 2B. NTP 7TH ANNUAL RPT ON CARCIN,
1994:ANTIC(ING 16)
Effects of Overexposure:HLTH HAZ:IF NOT REMOVED PROMPTLY INJURES TISS;
POSS PERM DMG. EYE, SKIN, ESOPHAGUS, STOMACH, NOSE & THROAT IRRIT.
SKIN:DEFAT, DERM. TOX BY ABSORPTION W/INHAL EFTS. MAY CAUSE SENSIT
RXN IN SUSCEPTIBLEPERS. POSS ALLERGIC RXN. BRIEF CNTCT MAY IRRIT
W/ITCH & LOC REDNESS. INHAL:NOSE & THROAT IRRIT. EXPOS ABOVE
RECD(ING 18)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH IMMED W/PLENTY OF WATER FOR AT LST 15 MIN & GET MED
ATTN IMMED. SKIN:WASH W/SOAP & WATER IMMED. REMOVE CONTAMD CLTHG
INCL SHOES. CONSULT MD IF IRRIT PERSISTS. LAUNDER CLTHG BEFORE
REUSE. DO NOT REUSE LEATHER/ABSORB SHOES. APPLY GOOD QUALITY SKIN
CREAM IF IRRIT PERSISTS. CONSULT MD. INHAL:REMOVE TO FRESH AIR
IMMED. IF SYMPS DEVELOP, SEEK MED ATTN AT ONCE. INGEST:GET MED ATTN
(ING 22)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:50.0F,10.0C
Lower Limits:0.3%
Upper Limits:25%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FAOM, WATER FOG.
Fire Fighting Procedures:NIOSH APPRVD PRESS DEMAND SCBA & FULL PROT
EQUIP H*2O SPRAY MAY BE USED TO REDUCE RATE OF BURN & TO COOL
CNTNRS. DURING EMER CNDTNS DECOMP PRODS (SUPDAT)
Unusual Fire/Explosion Hazard:THERMAL DECOMP PRODS MAY INCLUDE PHOSGENE
VAPS MAY CAUSE FL FIRE. KEEP CNTNR TIGHTLY CLSD & ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & FLAME. NEVER USE(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNIT SOURCES (FLAMES/HOT
SURFS/ELEC/STATIC/ FRICTIONAL SPKS). AVOID BRTHG VAP. VENT AREA.
CNTN & REMOVE W/INERT ABSORB MATL (IE SAWDUST/VERMICULITE/SAND) &
NON-SPKG TOOLS; PLACE MATL IN CL SD CNTNR. CNTCT NEHC FOR MORE
SPECIFIC INFO.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM EXCESS HEAT, SPKS, OPEN
FLAME. KEEP CLOSURES TIGHT WHEN NOT IN USE. KEEP CNTNRS UPRIGHT TO
PVNT LEAK. STORE IN COOL, DRY PLACE.(ING 23)
Other Precautions:NO SMKNG IN AREA OF USE. DO NOT USE IN GEN VICIN OF
ARC WELDING/OPEN FLAMES/HOT SURFS. HEAT &/OR UV RADIA MAY CAUSE
FORM OF HCL &/OR PHOSGENE . PROTECT AGAINST PHYSICAL DMG.
OUTSIDE/DETACHED STO R PREF. AVOID PRLNGD/RPTD INHAL (ING 24)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . CONTACT NEHC FOR MORE SPECIFIC INFORMATION .
Ventilation:EFFICIENT LOCAL EXHAUST VENTILATION IS REQUIRED.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR PROTECTIVE CLOTHING TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING AND SMOKING. SMOKE IN
DESIGNATED AREAS ONLY.
Supplemental Safety and Health
FIRE FIGHT PROC: CAN CAUSE HLTH HAZ. BURNING PRDCES TOX FUMES. DO NOT
DIRECT SOLID STREAM OF WATER/FOAM INTO HOT, BURNING POOLS; MAY
CAUSE FROTH & INCR FIRE INTENSITY. EXPLO HAZ:WELD/CUT TORCH ON/NEAR
DRUM (EVEN EMPTY); PROD (EVEN JUST RESIDUE) CAN IGNITE EXPLO. CLSD
CNTNRS MAY EXPLODE WHEN EXPOS TO EXTREME (ING 13)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:104F,40C
Vapor Density:HVR/AIR
VOC Pounds/Gallon:698
VOC Grams/Liter:5.83
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID PAINT; PETROLEUM ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HIGH TEMPS IN PRESENCE OF STRONG BASES, ACIDS, STRONG OXIDIZING AGENTS.
AVOID STRONG ACIDS & STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:VERY HIGH TEMPERATURE AND OPEN FLAMES. IF
THIS PRODUCT IS NOT WATER REDUCIBLE, AVOID WATER.
Hazardous Decomposition Products:PHOSGENE HCL, CO, CO*2 & ACETIC ACID.
VARIOUS HYDROCARBS. THERMAL DECOMP CAN PRDCE FUMES CNTNG ORG ACIDS,
CO*2,CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . CONTACT NEHC FOR MORE SPECIFIC
INFORMATION .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:M 615 RED OFFSET INK
Preparer's Name:L.M. FLAMBERG
CAGE:7F952
CAGE:7F952
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-BUTOXY-; (GLYCOL MONO BUTYL ETHER)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: >20%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:ETHANOL, 2-(2-BUTOXYETHOXY)-; (DIETHYLENE GLYCOL MONOBUTYL
ETHER)
CAS:112-34-5
RTECS #:KJ9100000
Fraction by Wt: >20%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ANIMAL STUDIES CLEARLY DEMONSTRATED
DOSE-RELATED ADVERSE EFFECTS ON CNS, HEMATOPOIETIC TISSUE, BLOOD,
KIDNEY AND LIVER, ASSOCIATED WITH ADMINISTRATION OF ETHYLENE GLYCOL
MONOBUTYL ETHER (EGBE) AND ETH YLENE GLYCOL MONOBUTYL ETHER ACETATE
(EGBEA). (EXTRACTED FROM DHHS (NIOSH) PUB NO. 90-118) . (EFTS OF
OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EYES:CAN CAUSE IRRITATION. SKIN:MAY
CAUSE IRRITATION. INHAL:MIST CAN CAUSE IRRITATION OF NASAL AND
RESPIRATORY PASSAGES. INGEST:CAN CAUSE GASTROINTESTINAL IRRITATION,
NAUSEA, VOMITING AND DIA RRHEA.
======================= First Aid Measures =======================
First Aid:SKIN:WASH WITH SOAP AND WATER. IMMEDIATELY REMOVE SOILED
CLOTHING. EYE:IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES
INCLUDING UNDER EYELIDS. GET MEDICAL HELP. INHAL:REMOVE TO FRESH
AIR. RESTOR E OR SUPPORT BREATHING, KEEP WARM AND AT REST. IF
IRRITATION PERSISTS, GET MEDICAL HELP. INGEST:GIVE WATER TO DILUTE.
INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:256F,124C
Extinguishing Media:SMALL FIRES:DRY CHEM/CO*2. LRG FIRES:WATER SPRAY,
FOG/FOAM. ALCOHOL FOAM, DRY CHEM OR CO*2. WATER MAY BE INEFT.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
A STREAM OF WATER CAN SCATTER FLAMES. USE WATER SPRAY TO COOL FIRE
EXPOSED CONTRS & TO DILUTE/FLUSH SOLV.
Unusual Fire/Explosion Hazard:CONTAINER MAY EXPLODE IN HEAT OR FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF IGNITION SOURCES; NO FLARES, SMOKING
OR FLAMES IN HAZARD AREA. DO NOT TOUCH SPILLED MATERIAL. SMALL
SPILLS:FLUSH AREA WITH FLOODING AMOUNTS OF WATER. LARGE SPILLS:WET
DOWN WITH WATER AND DIKE FOR LATER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AREAS OF USE AND STORAGE FOR THIS
MATERIAL SHOULD HAVE GOOD VENTILATION AND ALL SOURCES OF OPEN FLAME
AND HIGH HEAT SHOULD BE EXCLUDED.
Other Precautions:PROHIBIT SMOKING IN THESE AREAS. CONTAINERS OF THIS
MATERIAL MAY BE HAZARDOUS WHEN EMPTIED, ALL PRECAUTIONS GIVEN IN
MSDS MUST BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED, USE OF A NIOSH/MSHA APPROVED
RESPIRATOR IS ADVISED.
Ventilation:PROVIDE SUFFICIENT MECHANICAL VENTILATION TO MAINTAIN
EXPOSURE BELOW TLV.
Other Protective Equipment:USE EQUIPMENT TO PREVENT REPEATED OR
PROLONGED SKIN CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:451F,233C
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:RED SEMI PASTE INK WITH SLIGHT GLYCOL ETHER ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE CO
AND CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE MATERIAL BY INCINERATION OR
DISPOSE OF NEUTRALIZED WASTE IN A LANDFILL. FOLLOW LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-880-1650
Product ID: FLEETWELD 35
Cage: 36232
=======================================================
Contractor Summary
=======================================================
Cage: 36232
=======================================================
Item Description Information
=======================================================
Item Name: ROD,WELDING
=======================================================
Ingredients
=======================================================
Cas: 65996-61-4
% Wt: 5
OSHA PEL: 10 MG/M3 (MFR)
ACGIH TLV: 10 MG/M3 (MFR)
------------------------------
Cas: 7439-89-6
RTECS #: NO4565500
% Wt: <5
OSHA PEL: 10 MG/M3 (MFR)
ACGIH TLV: 10 MG/M3 (MFR)
------------------------------
Cas: 1344-09-8
% Wt: <5
OSHA PEL: 10 MG/M3 (MFR)
ACGIH TLV: 10 MG/M3 (MFR)
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
% Wt: <5
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 1309-48-4
RTECS #: OM3850000
% Wt: 1
OSHA PEL: 15 MG/M3 PARTICULATE
ACGIH TLV: 10 MG/M3; FUME
------------------------------
Cas: 7439-96-5
RTECS #: OO9275000
% Wt: 0.5
OSHA PEL: C 5 MG/M3 DUST
ACGIH TLV: 5 MG/M3 DUST
------------------------------
Cas: 684-08-7
% Wt: <0.5
OSHA PEL: 10 MG/M3 (MFR)
ACGIH TLV: 10 MG/M3 (MFR)
-----------------------------
Cas: 1332-58-7
RTECS #: GF1670500
% Wt: <0.5
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 2 MG/M3 TDUST
------------------------------
Cas: 7439-89-6
RTECS #: NO4565500
% Wt: 80
OSHA PEL: 10 MG/M3 (MFR)
ACGIH TLV: 10 MG/M3 (MFR)
------------------------------
DEGREASING ACTIVITIES). WHEN ELECTRODE IS
-----------------------------
PERCENT & FORM FROM INGS LISTED. DECOMP
-----------------------------
VOLATILIZATION, RXN/OXIDATION OF MATLS SHOWN IN INGS
-----------------------------
ABOVE. REASONABLY EXPECTED FUME
-----------------------------
COMPLEX OXIDES OF MANGANESE, POTASSIUM,
-----------------------------
& DIOXIDE. OZONE & NITROGEN OXIDES MAY BE
-----------------------------
FUMES & GASES TO WHICH WORKERS ARE EXPOSED BY
-----------------------------
BRTHG ZONE. IMPROVE VENT IF EXPOS ARE
-----------------------------
FROM AMERICAN WELDING SOCIETY.
-----------------------------
POSITIONS SUCH AS SITTING, KNEELING/LYING, IF
-----------------------------
USE THE FOLLOWING EQUIP: SEMIAUTOMATIC
-----------------------------
VOLTAGE CONTROL.
-----------------------------
PRINTING OFFICE, WASHINGTON, D.C. 20402 FOR MORE INFO.
-----------------------------
-----------------------------
WELL AS DARK SUBSTANTIAL CLOTHING.
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ELEC ARC WELDING MAY CREATE ONE/MORE OF THE FOLLOWING HLTH
HAZS: FUMES & GASES CAN BE DANGEROUS TO YOUR HLTH. ACUTE OVEREXP TO
WELDING FUMES MAY RSLT IN DISCOMFORT SUCH AS METAL FUME FEVER, DIZZ, NAUS
/DRYNESS/IRRIT OF NOSE, THROAT/EYES. CHRONIC OVEREXP TO WELDING FUMES CAN
LEAD TO SIDEROSIS (IRON (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: DEPOSITS IN LUNG) & MAY
AFFECT PULM FUNC. MANGANESE OVEREXP CAN AFFECT CNS, RSLTG IN IMPAIRED SPEECH
& MOVEMENT. BRONCH & SOME LUNG FIBROSIS HAVE BEEN REPORTED. ARC RAYS
CAN INJURE EYES & BU RN SKIN. SKIN CANCER HAS BEEN REPORTED.ELEC SHOCK
CAN KILL. IF WELDING MUST BE PERFORMED IN DAMP LOCATION, OR
Medical Cond Aggravated By Exposure: MAY AGGRAVATE PREEXISTING RESPIRATORY
PROBLEMS (E.G., ASTHMA, EMPHYSEMA).
First Aid: CALL FOR MED AID. EMPLOYE FIRST AID TECHNIQUES RECOMMENDED BY
AMERICAN RED CROSS. INHAL: IF BREATHING DIFFICULT, GIVE OXYGEN. IF NOT
BREATHING, GIVE CPR. IN CASE OF ELEC SHOCK, TURN OFF POWER & FOLLOW
RECOMMENDED TREATMENT. IN ALL CASES, CALL MD. EYES: FLUSH W/POTABLE WATER FOR
AT LEAST 15 MIN. SEE MD (FP N). SKIN: WASH W/COPIOUS AMOUNTS OF WATER. SEE MD
(FP N). INGEST: CALL MD IMMED (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER, OR
LINER AS ORDINARY WASTE IN AN ENVIRONMENTALLY ACCEPTABLE MANNER ACCORDING TO
FEDERAL, STATE AND LOCAL REGULATIONS UNLESS OTHERWISE NOTED.
Handling And Storage Precautions: TRAIN WELDER NOT TO PERMIT ELEC LIVE
PARTS/ELECTRODES TO CONT SKIN/CLTHG IF THEY ARE WET, & TO KEEP HEAD OUT
OF FUMES. INSULATE FROM WORK & GROUND.
Other Precautions: READ & UNDERSTAND MFR'S INSTRUCTIONS & PREC LABEL ON
PROD. REQUEST LINCOLN SFTY PUBLICATION E205. SEE AMERICAN NATL STD Z49.1,
"SFTY IN WELDING & CUTTING", PUBLISHED BY AMERICAN WELDING SOCIETY, 550 N
.W. LEJEUNE RD, MIAMI, FL,
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: USE MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NON FLAMMABLE; WELDING ARC AND SPARKS CAN IGNITE
COMBUSTIBLES AND FLAMMABLE PRODUCTS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH APPROVED RESPIRABLE FUME RESPIRATOR OR AIR
SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACE OR GENERAL WORK AREA WHEN
LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation: ENOUGH VENT, LOC EXHST AT ARC/BOTH TO KEEP FUMES & GASES FROM
WORKER'S BRTHG ZONE & GEN AREA. KEEP EXPOS AS LOW AS POSS.
Other Protective Equipment: ANSI APPRVD EMER EYEWASH & DELUGE SHOWER (FP N).
WEAR HAND, HEAD, & BODY PROT WHICH HELP TO PVNT INJURY FROM
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: HAZ DECOMP PROD: WELDED, PROCESS, PROC &
ELECTRODES USED. OTHER CNDTNS WHICH ALSO INFLUENCE INCL: COATINGS ON METAL
BEING WELDED (PAINT, PLATING/GALVANIZING), NUMBER OF WELDERS & VOL OF
WORKER AREA, Q UALITY & AMT OF VENT, POSITION OF WELDER'S HEAD W/RESPECT
TO FUME PLUME, AS WELL AS PRESENCE OF CONTAMINANTS IN
=======================================================
Physical/Chemical Properties
=======================================================
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: WELDING FUMES & GASES CANNOT BE CLASSIFIED
SIMPLY. COMPOSITION & QTY OF BOTH ARE DEPENDENT UPON METAL BEING (SUP DAT)
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 137516
Product ID: FLEETWELD 35
Review Date: 01/13/1999
Multiple KIT Number: 0
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: FLEETWELD 35
Cage: 36232
Company Name: THE LINCOLN ELECTRIC CO
Street: 22801 ST CLAIR AVE
Zipcode: 44117-1199
Label Required IND: Y
Date Of Label Review: 08/18/1998
Status Code: C
Label Date: 08/18/1998
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ELECTRIC ARC WELDING MAY CREATE ONE OR MORE OF THE
FOLLOWING HEALTH HAZARDS: FUMES AND GASES CAN BE DANGEROUS TO YOUR HEALTH.
ACUTE OVEREXPOSURE TO WELDING FUMES MAY RESULT IN DISCOMFORT SUCH AS METAL
FUME FEVER, DIZZINESS, NAUSEA/DRYNESS/IRRITATION OF NOSE, THROAT OR EYES.
CHRONIC OVEREXPOSURE TO WELDING FUMES CAN LEAD TO SIDEROSIS (IRON DEPOSITS IN
LUNGS) AND MAY AFFECT PULMONARY FUNCTION. MANGA NESE OVEREXPOSURE CAN AFFECT
CENTRAL NERVOUS SYSTEM RESULTING IN IMPAIRED SPEECH AND MOVEMENT. BRONCHITIS
AND SOME LUNG FIBROSIS HAVE BEEN REPORTED. ARC RAYS CAN INJURE EYES AND BURN
SKIN. ELECTRIC SH OCK CAN KILL. SKIN CANCER HAS BEEN REPORTED.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CONFIDENT EXTERIOR LATEX FLAT FINISH, 217-1
CAGE:85231
CAGE:59019
CAGE:85231
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYES/SKIN/UPPER RESP
SYS. IN A CONFINED AREA VAPS IN HIGH CONC MAY CAUSE HDCH/NAUS/DIZZ.
CHRONIC:LONG TERM EXPOS TO HIGH LEVELS OF SILICA DUST, WHICH CAN
OCCUR ONLY WHEN SANDING/ABRADIN G DRY FILM, MAY CAUSE LUNG DAM
(SILICOSIS) & POSS CANCER. ETHYLENE GLYCOL IS CONSIDERED AN ANIMAL
TERATOGEN. (SUPP DATA)
Explanation of Carcinogenicity:CRYSTALLINE SILICA: GROUP 2A (IARC).
Effects of Overexposure:REDNESS AND ITCHING OR BURNING SENSATION MAY
INDICATE EYE OR EXCESSIVE SKIN EXPOSURE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM AND
QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE. EYES: FLUSH
EYES W ITH LARGE AMOUNTS OF WATER FOR AT LEAST15 MINUTES. GET
MEDICAL ATTENTION. INGEST: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>199F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY BE INEFT. IF WTER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD (SUPP DATA)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR CLSD WHEN NOT IN USE.
TRANSFER ONLY TO APPRVD CNTNRS W/COMPLETE & APPROP LABELING. DO NOT
TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:USE ONLY W/ADEQ VENT. AVOID BRTHG VAP & SPRAY MIST.
AVOID CONT W/SKIN & EYES. COATING MAY CONTAIN MATLS CLASSIFIED AS
NUISANCE PARTICULATES WHICH MAY BE PRESENT AT HAZ LEVELS ONLY
DURING SANDING OR AB RADING OF THE DRIED FILM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMITS BY VENT, WEAR A PROPERLY FITTED ORG VAP/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROT AGAINST MATLS. WHEN
SANDING, WIREBRUSHING, ABRADIN G, BURNING OR WELDING THE (ING 9)
Ventilation:LOCAL EXHAUST PREF. GEN EXHAUST ACCEPTABLE IF THE EXPOS TO
MATLS IS MAINTAINED BELOW APPLIC EXPOS LIMITS. (ING 10)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC: CNTNRS TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPOL
WHEN EXPOS TO EXTREME HEAT. HLTH HAZ: IT HAZ BEEN SHOWN TO CAUSE
BIRTH DEFECTS IN RATS & MICE AT HIGH DOSES WHEN GIVEN IN DRINKING
WATER/BY GAVAGE. THERE IS NO EVIDENCE TO INDICATE IT CAUSES BIRTH
DEFECTS IN HUMANS. (ING 6)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
pH:ING 11
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:59-78
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PRODUCT IS NOT HAZARDOUS AS
DEFINED UNDER THE RCRA 40 CFR 261. INCINERATE IN APPROVED FACILITY.
DO NOT INCINERATE CLOSED CONTAINER. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOC AL REGULATIONS REGARDING POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BENZYL ALCOHOL, 5190
CAGE:DO803
CAGE:DO803
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:BENZYL ALCOHOL
CAS:100-51-6
RTECS #:DN3150000
Fraction by Wt: 90-100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 1230 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:HEADACHE, NAUSEA,
VOMITING, DIZZINESS, DROWSINESS, IRRITATION OF UPPER RESPIRATORY
TRACT, NARCOSIS, CENTRAL NERVOUS SYSTEM DEPRESSION,
UNCONSCIOUSNESS, MAY CAUSE PULMONARY EDEMA. SKIN
CONTACT:IRRITATION, PROLONGED CONTACT MAY CAUSE DERMATITIS. EYE
CONTACT:IRRITATION, MAY CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:TEMPORARY CORNEAL DAMAGE. SKIN
ABSORPTION:MAY BE HARMFUL. INGESTION:HEADACHE, NAUSEA, VOMITING,
GASTROINTESTINAL IRRITATION, CONVULSIONS, CENTRAL NERVOUS SYSTEM
DEPRESSION, UNCONSCIOUSNESS. C HRONIC:NONE IDENTIFIED. TARGET
ORGANS:RESPIRATORY SYSTEM, LUNGS, CENTRAL NERVOUS SYSTEM, EYES,
SKIN.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD. IF SWALLOWED, IF CONSCIOUS, IMMEDIATELY
INDUCE VOMITING. INHAL:REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTF RESP. IF BREATHING IS DIFFICULT, GIVE OXYGEN. SKIN:IMMEDIATELY
FLUSH W/P LENTY OF WATER FOR AT LEAST 15 MINUTES WHILE REMOVING
CONTAMINATED CLOTHING & SHOES. WASH CLOTHING BEFORE RE-USE.
EYES:IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:212F,100C
Extinguishing Media:USE ALCOHOL FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
(WATER MAY BE INEFFECTIVE).
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIP . MOVE CNTNRS FROM FIRE AREA IF IT CAN BE DONE W/OUT RISK.
USE WATER TO KEEP FIRE-EXPOS CNTNRS COOL.
Unusual Fire/Explosion Hazard:WHEN EXPOSED TO HEAT, CLSD CNTNRS MAY
EXPLODE; MAY ALSO GIVE OFF HIGHLY TOXIC/IRRITATING FUMES. CONTACT
W/STRONG OXIDIZERS MAY CAUSE FIRE OR EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT CLTHG.
SHUT OFF IGNIT SOURCES; NO FLARES, SMOKING/FLAMES IN AREA. STOP
LEAK IF YOU CAN DO SO W/OUT RISK. USE WATER SPRAY TO REDUCE VAPS.
TAKE UP W/SAND OR OTHER NON-COMBUST ABSORB MATL & PLACE INTO (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:GENERAL STORAGE. KEEP CONTAINER
TIGHTLY CLOSED. STORE IN COOL, DRY, WELL-VENTILATED AREA AWAY FROM
HEAT, SPARKS OR FLAME. KEEP PRODUCT OUT OF LIGHT.
Other Precautions:ISOLATE FROM INCOMPATIBLE MATERIALS. CAUSES
IRRITATION. HARMFUL IF SWALLOWED, INHALED OR ABSORBED THROUGH SKIN.
AVOID CONTACT W/EYES, SKIN, CLOTHING. AVOID BREATHING VAPOR. USE
W/ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, USE A
NIOSH/MSHA APPROVED RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
VAPOR & MIST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . UNIFORM, APRON ARE RECOMMENDED. LAB (SUPDAT)
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPILL PROC:CONTAINER FOR LATER DISPOSAL. FLUSH AREA W/WATER. J.T. BAKER
SOLUSORB SOLVENT ABSORBENT IS RECOMMENDED FOR SPILLS OF THIS
PRODUCT. OTHER PROT EQUIP:COAT. WHEN HANDLING LIQ PRODS, SECONDARY
PROT CONTAINERS MUST BE USED FOR CARRYING.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:401F,205C
Melt/Freeze Pt:M.P/F.P Text:5F,-15C
Vapor Pres:0.15 @ 20C
Vapor Density:3.7
Spec Gravity:1.05 (H*2O=1)
Solubility in Water:MODERATE (1-10%)
Appearance and Odor:CLEAR, COLORLESS LIQUID; FAINT AROMATIC ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, PLASTICS.
Stability Condition to Avoid:HEAT, FLAME, OTHER SOURCES OF IGNITION,
AIR.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL APPLICABLE FEDERAL, STATE &
LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NORSOPHEN NP-103 PART A
Kit Part:Y
CAGE:NRLDC
CAGE:NRLDC
============= Composition/Information on Ingredients =============
Ingred Name:FORMALDEHYDE (SARA III). LD50:(ORAL RAT) 800 MG/KG
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: 0.2-1%
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM; A2; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:PHENOL (SARA III). LD50:(ORAL RAT) 414 MG/KG
CAS:108-95-2
RTECS #:SJ3325000
Fraction by Wt: 7-11%
OSHA PEL:5 PPM, S
ACGIH TLV:5 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 5-10%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SUPP DATA:STAGES OF SEV POISONING. NOTE:FORMALDEHYDE IS A
LISTED CARCIN. OBSERVATIONS SUGGEST THAT ETHYLENE (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:GLYCOL IS TO BE REGARDED AS AN ANIMAL TERATOGEN;
THERE IS CURRENTLY NO AVAIL INFO TO SUGGEST THAT ETHYLENE (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:GLYCOL HAS CAUSED BIRTH DEFECTS IN HUMANS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:IF IRRITATION OR OTHER SYMPTOMS PERSIST,
OBTAIN MED ATTN IMMEDIATELY. INGEST:CONTACT MD IMMEDIATELY.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:DISP MATL I/A/W MUNICIPAL, PROVINCIAL & FED
REGS. IN THE EVENT OF LGE SPILL, DIKE AREA TO PVNT ENTRY (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:INTO NATURAL BODIES OF WATER OR SEWERS. NOTIFY
GOVERNMENT AGENCIES IN THE EVENT OF RELS OF MATL INTO ENVIRON.
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN:ANTICIPATED TO BE A CARCINOGEN. OSHA
REGULATED, 29 CFR 1910.48.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHAL: ING 2 - VAP/MIST ARE IRRITATING
TO NOSE & THROAT. PRLNGD EXPOS CAN RSLT IN DIZZ, VISUAL DISTURB,
IRREG PULSE OR BRTHG & HDCH; POSS LIVER & KIDNEY DAM FROM LGE
EXPOS. ING 1 - IRRIT OF NOSE & THR OAT, BRONCH & BRONCHOPNEUMONIA.
THESE SYMPS USUALLY APPEAR >1 PPM. EYE CONT:VAPS ARE IRRITATING TO
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:FORMALDEHYDE: IARC MONOGRAPHS,
SUPPLEMENT, VOL 7, PG 211, 1987:GROUP 2A. NTP 6TH ANNUAL REPORT ON
CARCINS, 1991.(ING 10)
Effects of Overexposure:HLTH HAZ:EYES. SOLNS ARE SEVERELY IRRITATING TO
EYES. PERM EYE DAM CAN OCCUR. SKIN CONT:CONT W/RESIN SOLN CAN CAUSE
SKIN IRRIT. RPTD EXPOS MAY RSLT IN SKIN SENSIT & DERM. INGEST:MAY
CAUSE STOM DISCOMF ORT OR PAIN, NAUS, VOM, DIZZ, DROW, MALAISE,
BLURRING OF VISION, IRRITABILITY, LUMBAR PAIN, OLIGURIA, UREMIA &
(SUP DAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE SOURCE OF CONTAM OR MOVE VICTIM TO FRESH AIR. IF
BRTHG IS DFCLT, OXYGEN MAY BE BENEFICIAL IF ADMIN BY PERS TRAINED
IN ITS USE, PREF ON MD'S ADVICE. OBTAIN MED ATTN IMMED. EYES:IMMED
FLUSH W/LUKEWARM, GENTLY FLOWING WATER FOR AT LEAST 20 MINS
HOLDING EYELIDS OPEN. OBTAIN MED ATTN IMMED. SKIN:IMMED FLUSH
CONTAMD AREA W/LUKEWARM, GENTLY RUNNING WATER FOR AT LEAST 20
MINS.(ING 7)
===================== Fire Fighting Measures =====================
Flash Point:>212F,>100C
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . CLOSED CONTAINERS MAY RUPTURE IF EXPOSED TO
EXTREME HEAT.
Unusual Fire/Explosion Hazard:INCOMPLETE COMBUSTION CAN YIELD CARBON
MONOXIDE & OTHER TOXIC GASES.
================== Accidental Release Measures ==================
Spill Release Procedures:RESTRICT ACCESS TO AREA UNTIL COMPLETION OF
CLEAN-UP. ENSURE CLEAN-UP IS CONDUCTED BY TRAINED PERS ONLY. WEAR
ADEQ PROT EQUIP. VENT AREA. STOP/REDUCE LEAK IF SAFE TO DO SO.
ABSORB SPILL W/ABSORB MATLSUCH AS SAWDUST, VERMICULITE OR SAND.
(ING 8)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, WELL VENTILATED AREA,
OUT OF DIRECT SUNLIGHT & AWAY FROM INCOMPATIBLE MATERIAL & ANY
SOURCE OF HEAT.
Other Precautions:AVOID SKIN & EYE CONTACT. WEAR APPROPRIATE PERSONAL
PROTECTIVE EQUIPMENT. AVOID GENERATING MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP PROT MAY BE REQUIRED IF
MATERIAL IS USED IN POORLY VENTD AREA OR IF MATERIAL IS SPRAYED OR
HEATED. IF RESP PROT IS REQUIRED, INSTITUTE A COMPLETE RESP PROT
PROGRAM.
Ventilation:GENERAL (DILUTION) VENTILATION IS USUALLY SUFFICIENT. LOCAL
EXHST VENTILATION MAY BE REQD IF MATL IS SPRAYED OR HEATED.
Other Protective Equipment:EYEWASH FOUNTAIN & SAFETY SHOWER MUST BE
AVAILABLE IN AREAS WHERE THIS MATERIAL IS USED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
KEY1;C4.EFTS OF OVEREXP:CNS EFTS, INCL IRREG EYE MOVEMENTS, CONVL &
COMA. CARD FAILURE & PULM EDEMA MAY DEVELOP. SEV KIDNEY DAM FOLLOWS
SWALLOWING OF LGE VOLUMES. MAY BE FATAL. A FEW RPTS HAVE BEEN PU
BLISHED DESCRIBING DEVELOPMENT OF WEAKNESS OF THE FACIAL MUSCLES,
DIMINISHED HEARING & DFCLTY W/SWALLOWING, DURING LATE
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32F,0C
Vapor Pres:OF WATER
Vapor Density:0.62
Spec Gravity:1.1-1.3
pH:<10.5
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:LIMITED
Appearance and Odor:BROWNISH LIQUID W/PHENOLIC & FORMALDEHYDE ODOR.
Percent Volatiles by Volume:25
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
STRONG ACIDS, STRONG BASES & OXIDIZING AGENTS.
Stability Condition to Avoid:STORAGE OF MATERIAL IN HOT AREAS.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE W/FEDERAL, STATE
& LOCAL REGULATIONS .
| 1 | gloves_mandatory |
=======================================================
Product ID: MILLENIUM 2100 COVE BASE
Cage: 15934
Box: 127
=======================================================
Contractor Summary
=======================================================
Cage: 15934
Box: 127
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Other REC Limits: N/K (FP N)
OSHA PEL: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
ACGIH STEL: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EYES: MAY CAUSE SLIGHT IRRITATION. SKIN: NO EFFECT
KNOWN. INGESTION: NOT LIKELY TO OCCUR. IF SWALLOWED, NO SIDE EFFECTS KNOWN.
INHALATION: NO EFFECT KNOWN. CHRONIC: NONE KNOWN.
Explanation Of Carcinogenicity: THIS PRODUCT CONTAINS NO INGREDIENT LISTED AS A
CARCINOGEN BY IARC, NTP, OR OSHA.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
First Aid: EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CONTACT A PHYSICIAN
IF IRRITATION OCCURS. SKIN: WASH WITH SOAP AND WATER. INGESTION: INDUCE
VOMITING. CONTACT A PHYSICIAN. INHALATION: REMOVE TO FRESH A IR. SUPPORT
BREATHING (GIVE OXYGEN OR ARTIFICIAL RESPIRATION) (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: DISPENSE SAND, SAWDUST, OR VERMICULITE. COLLECT AND
PLACE IN WASTE CONTAINER. WASH AREA THOROUGHLY WITH WATER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
Handling And Storage Precautions: KEEP OUT OF THE REACH OF CHILDREN. STORE
ABOVE 40F.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Lower Limits: NONE
Upper Limits: NONE
Extinguishing Media: WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, AND CHEMICAL
FOAM.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: DRIED MATERIAL MAY PRODUCE CARBON MONOXIDE,
CARBON DIOXIDE, WATER, NO*X, AND OTHER PRODUCTS FROM THE BURNING OF AROMATIC
HYDROCARBONS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NORMALLY REQUIRED WITH GOOD VENTILATION. WEAR NIOSH
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: NORMAL ROOM VENTILATION.
Other Protective Equipment: EYEWASH AND DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N).
Work Hygienic Practices: USE GOOD HYGIENIC PRACTICES. WASH HANDS BEFORE EATING,
USING WASHROOM, OR SMOKING.
Supplemental Safety and Health: PHYSICAL/CHEMICAL PROPERTIES: VAPOR DENSITY
(AIR=1): SAME AS WATER; % VOLATILE BY WEIGHT: 36; GRAMS VOLATILE ORGANIC
COMPOUNDS/LITER OF COATING: 0 (BASED ON NO SOLVENT); GRAMS VOLATILE ORGANIC
COMPOUN DS/LITER OF MATERIAL: 0 (BASES ON NO SOLVENT).
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: =100.C, 212.F
Vapor Pres: SAME AS WATER
Vapor Density: SUP DAT
Spec Gravity: 1.4 (WATER=1)
PH: 9.7
Appearance and Odor: LIGHT TAN COLORED PASTE.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE KNOWN.
Hazardous Decomposition Products: NONE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE KNOWN.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: THIS PRODUCT HAS BEEN TESTED FOR TOXICITY (ACUTE
INHALATION; ACUTE DERMAL; SKIN IRRITATION; ORAL) AND HAS BEEN FOUND TO BE
NON-TOXIC AS DEFINED BY THE FEDERAL HAZARDOUS SUBSTANCE ACT, 16 CFR 1500.3.
=======================================================
Ecological Information
=======================================================
Ecological: NO INFORMATION AVAILABLE.
=======================================================
=======================================================
Transport Information: FOR DOMESTIC TRANSPORTATION PURPOSE, THIS PRODUCT IS NOT
DESIGNATED AS A HAZARDOUS MATERIAL BY THE U.S. DEPARTMENT OF TRANSPORTATION.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SECTION 311 AND 312 HEALTH AND PHYSICAL HAZARDS:
IMMEDIATE.
Federal Regulatory Information: TSCA: ALL INGREDIENTS ARE LISTED.
=======================================================
Other Information
=======================================================
Other Information: RATINGS: HEALTH=1; FLAMMABILITY=1; REACTIVITY=0; PERSONAL
PROTECTIVE EQUIPMENT=B. HAZARD RATING SCALE: 0=MINIMAL; 1=SLIGHT; 2=MODERATE;
3=SERIOUS; 4=SEVERE. CHEMICAL FAMILY: WATER BASSE ADHESIVE. NOT HAZARDOUS AS
DEFINED BY OSHA 29 CFR 1910.1200.
=======================================================
HAZCOM Label
=======================================================
Product ID: MILLENIUM 2100 COVE BASE
Cage: 15934
Company Name: PARA CHEM
PO Box: 127
Zipcode: 29681
Label Required IND: Y
Date Of Label Review: 08/03/1999
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYES: MAY CAUSE SLIGHT IRRITATION. SKIN: NO
EFFECT KNOWN. INGESTION: NOT LIKELY TO OCCUR. IF SWALLOWED, NO SIDE EFFECTS
KNOWN. INHALATION: NO EFFECT KNOWN. CHRONIC: NONE KNOWN.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METHYL ALCOHOL 14280, A452RS28
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ALCOHOL; (METHANOL) (SARA 313) (CERCLA)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: >99%
OSHA PEL:S, 200 PPM
ACGIH TLV:S, 200 PPM/250 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SUPDAT: ALUMINUM SALTS, BERYLLIUM, DIHYDRIDE, CARBON
TETRACHLORIDE & METALS, CHLOROFORM & HEAT, CHLOROFORM & (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: SODIUM HYDROXIDE, CYANURIC CHLORIDE, DIETHYL ZINC,
NITRIC ACID, & POTASSIUM TERTBUTOXIDE. PLEASE REFER (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: TO NFPA FIRE PROTECTION GUIDE FOR ALL SPECIFICS.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: DESCRIBED FOR INGESTION. CHRONIC:
PROLONGED OR REPEATED SKIN CONT MAY CAUSE DERMATITIS. (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: CHRONIC INHALATION AND INGESTION MAY CAUSE EFFECTS
SIMILAR TO THOSE OF ACUTE INHALATION AND INGESTION. (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: TARGET ORGANS: KIDNEYS, CENTRAL NERVOUS SYSTEM,
LIVER, EYES.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: TEASPOON OF SYRUP OF IPECAC. INHAL: GET MED
AID IMMED. REMOVE FROM EXPOSURE TO FRESH AIR IMMED. (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: IF NOT BRTHG, GIVE ARTIFICIAL RESPIRATION. IF BRTHG
IS DIFFICULT, GIVE OXYGEN. NOTES TO PHYS: EFFECTS (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: MAY BE DELAYED. ETHANOL MAY INHIBIT METABOLISM. NO
SPECIFIC ANTIDOTE EXISTS.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: OR VERMICULITE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) 5628 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: CAUSES MOD IRRIT. VAPS CAN
CAUSE EYE IRRIT. MAY CAUSE PAINFUL SENSITIZ TO LIGHT. SKIN: MAY
CAUSE IRRIT. MAY BE ABSORBED THRU SKIN IN HARMFUL AMTS. INGEST: MAY
CAUSE IRRIT OF DIGESTIVE TRAC T. MAY CAUSE CNS DEPRESS, CHARACT BY
EXCITEMENT, FOLLOWED BY HDCH, DIZZ, DROW, & NAUS. ADVANCED STAGES
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: MAY CAUSE COLLAPSE, UNCON, COMA &
POSS DEATH DUE TO RESP FAILURE. MAY CAUSE KIDNEY FAILURE. INHAL:
MAY CAUSE RESP TRACT IRRIT. MAY CAUSE LIVER & KIDNEY DMG. MAY CAUSE
ADVERSE CNS EFTS INCL H DCH, CONVLS, & POSS DEATH. MAY CAUSE VISUAL
IMPAIRMENT & POSS PERM BLNDNESS. MAY CAUSE EFTS SIMILAR TO THOSE
(ING 5)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR @ LST 15 MINS, OCCASNLY
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW VICTIM
TO RUB/KEEP EYES CLSD. SKIN: FLUSH W/PLENTY OF SOAP & WATER FOR @
LST 15 MI NS WHILE REMOVING CONTAMD CLTHG & SHOES. GET MED AID IF
IRRIT DEVELOPS/PERSISTS. INGEST: IF CONSCIOUS & ALERT, GIVE 2-4
CUPFULS OF MILK/WATER. GET MED AID IMMED. INDUCE VOMIT BY GIVING
ONE (ING 8)
===================== Fire Fighting Measures =====================
Flash Point:53F,12C
Lower Limits:6.0%
Upper Limits:31.0%
Extinguishing Media:SM FIRES, USE DRY CHEM, CO*2, WATER
SPRAY/ALCOHOL-RESIST FOAM. USE WATER SPRAY TO COOL FIRE-EXPOS
CNTNRS. WATER (SUPDAT)
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CNTNRS CAN BUILD UP PRESS IF EXPOS TO
HEAT &/OR FIRE. VAPS CAN TRAVEL TO SOURCE OF IGNIT & FLASH BACK.
DURING FIRE, IRRITATING & HIGHLY TOX GASES MAY BE(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROT EQUIP AS INDICATED.
SCOOP UP W/NONSPK TOOL, THEN PLACE INTO SUITABLE CNTNR FOR DISP.
USE WATER SPRAY TO DISPERSE GAS/VAP. REMOVE ALL SOURCES OF IGNIT.
ABSORB SPILL USING ABSOR B, NON-COMBUST MATL SUCH AS EARTH, SAND,
(ING 11)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNIT. STORE
IN COOL, DRY, WELL-VENTILATED AREA AWAY FROM INCOMPATIBLE
SUBSTANCES. FLAMMABLE-AREA. USE W/ADEQUATE VENT.
Other Precautions:EMPTY CNTNRS RETAIN PROD RESIDUE, (LIQUID AND/OR
VAPOR), AND CAN BE DANGEROUS. DO NOT GET ON SKIN/IN EYES. DO NOT
INGEST/INHALE. DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND/EXPOSE EMPTYCNTNRS TO HEAT, SPARKS/OPEN FLAMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29CFR 1910.134. ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQ GEN/LOC EXHAUST VENT TO KEEP AIRBORNE CONCS BELOW
PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . WEAR
APPROP PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
EXTING MEDIA: MAY BE INEFTIVE. EXPLO HAZ: GENERATED BY THERM
DECOMP/COMBUST. FLAMM LIQ. CAN RELEASE VAPS THAT FORM EXPLO MIX @
TEMPS ABOVE FLASHPOINT. MATLS TO AVOID: SODIUM HYPOCHLORITE).
ACTIVE META LS (SUCH AS POTASSIUM & MAGNESIUM). SUBSTANCE IS ALSO
INCOMPAT W/SPECIFIC CHEMS INCL: ACETYL BROMIDE, ALKYL (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:148F,65C
Melt/Freeze Pt:M.P/F.P Text:-144F,-98C
Vapor Pres:96
Vapor Density:1.1
Spec Gravity:0.7910
Evaporation Rate & Reference:5.2 (ETHER = 1)
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID. SLIGHT ALCOHOL-LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDANTS (SUCH AS BARIUM PERCHLORATE, BROMINE, CHLORINE, HYDROGEN
PEROXIDE, LEAD PERCHLORATE, PERCHLORIC ACID, (SUPDAT)
Stability Condition to Avoid:STABLE AT ROOM TEMP IN CLSD CNTNRS UNDER
NORM STOR & HNDLG CNDTNS. HIGH TEMPS, INCOMPATIBLE MATLS, IGNITION
SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
FORMALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PSI-601 SILICONE SEALANT
Kit Part:Y
Preparer's Name:ED CLUFF
CAGE:0KND3
CAGE:0KND3
============= Composition/Information on Ingredients =============
Ingred Name:METHYLTRIACETOXYSILANE
CAS:4253-34-3
RTECS #:VV4500000
Fraction by Wt: 2-6%
Other REC Limits:NONE SPECIFIED
Ingred Name:ETHYLTRIACETOXYSILANE
CAS:17689-77-9
Fraction by Wt: 2-6%
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC: 0.4 LBS/GAL; 40 GRAMS/LITER
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC: 6.5 LBS/GAL; 780 GRAMS/LITER
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SEVERE IRRITATION TO
RESPIRATORY TRACT, PULMONARY EDEMA, EYE LACRIMATION, CORNEAL EDEMA;
SKIN IRRITATION AND DERMATITIS. CHRONIC: BRONCHITIS, LARYNGITIS;
DERMATITIS; CONJUNCTIVITIS.
Explanation of Carcinogenicity:NOT CARCINOGENIC
Effects of Overexposure:IRRITATION TO SKIN, EYES AND MUCOUS MEMBRANES.
MAY CAUSE DISCOMFORT, TEARING, CHOKING OR BURNING SENSATION.
Medical Cond Aggravated by Exposure:RESPIRATORY, SKIN OR EYE DISEASES.
======================= First Aid Measures =======================
First Aid:REMOVE TO FRESH AIR. WASH SKIN WITH SOAP AND WATER. FLUSH
EYES WITH WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>400F,>204C
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICALS, FOAM, SAND
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS
OPERATED IN POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:TOXIC GASES AND AEROSOLS MAY BE PRODUCED
BY COMBUSTION (CO AND SIO2).
================== Accidental Release Measures ==================
Spill Release Procedures:MATERIAL RELEASES ACETIC ACID ON EXPOSURE TO
AIR. PROVIDE ADEQUATE VENTILATION DURING CLEAN UP. WEAR PROPER
PROTECT EQUIPMENT IF HANDLING LARGE AMOUNTS. TRANSFER TO WASTE
CONTAINER. LET CURE TO SOLID RUBBER, LET ALL LIBERATED ACETIC ACID
DISSIPATE.
Neutralizing Agent:AQUEOUS SODIUM BICARBONATE
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED SKIN CONTACT.
LIBERATED ACETIC ACID VAPORS CAUSE IRRITATION TO SKIN, EYES AND
BRONCHIAL TISSUES. DO NOT INGEST.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CLOSED SPACE WITH INADEQUATE VENTILATION USE
CHEMICAL CARTRIDGE RESPIRATOR WITH FULL FACE PIECE & ORGANIC VAPOR
CARTRIDGE (NIOSH/MSHA APPROVED) TO PROTECT AGAINST ACETIC ACID
VAPORS.
Ventilation:RECOMMENDED 10 AIR CHANGES PER HOUR
Other Protective Equipment:NONE
Work Hygienic Practices:WASH BEFORE EATING, DRINKING OR SMOKING. DO NOT
RUB EYES WHILE WORKING WITH SEALANT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:C3
Decomp Temp:Decomp Text:>752F,>400C
Vapor Pres:< 5 MM
Vapor Density:2.07
Spec Gravity:1.05
pH:3-5
Viscosity:10-20000POISE
Solubility in Water:MODERATE
Appearance and Odor:THICK PASTE, VINEGAR LIKE ODOR
Percent Volatiles by Volume:4-7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID PROLONGED CONTACT WITH MOISTURE DURING STORAGE.
Hazardous Decomposition Products:ACETIC ACID FROM MOISTURE CONTACT. CO
AND VOLATILE ORGANICS AND SILICA AEROSOLS FROM THERMAL DEGRADATION.
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT AN EPA HAZARDOUS WASTE. DISPOSE OF IN
ACCORDANCE WITH APPROPRIATE GOVERNMENTAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-267-7188
Product ID: CHRISTO-LUBE MCG 200
Cage: 0JRD3
=======================================================
Contractor Summary
=======================================================
Cage: 0JRD3
Cage: 0PGK2
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: GREASE,AIRCRAFT
Unit of Issue: TU
Quantitative Expression: 00000000005GM
UI Container Qty: 0
Type of Container: TUBE
=======================================================
Ingredients
=======================================================
% Wt: 100
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NOT GIVEN FOR PRODUCT AS A WHOLE
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: NONE SPECIFIED BY MANUFACTURER.
Explanation Of Carcinogenicity: THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Signs And Symptions Of Overexposure: NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHALATION: REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF
BREATHING HAS STOPPED. EYES: FLUSH WITH WATER AND CONSULT PHYSICIAN. SKIN:
WASH WITH SOAP AND WATER. IF IRRITATION OCCURS, CALL PHYSICIA N. INGESTION:
DRINK MILK OR WATER. DO NOT INDUCE VOMITING. CALL PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: USE ABSORBENT MATERIAL TO COLLECT AND CONTAIN FOR
SALVAGE OR DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR LINER IN
ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
Handling And Storage Precautions: STORE IN COOL WELL VENTILATED AREA OF LOW
FIRE RISK. AVOID BREATHING VAPORS. USE SELF-CONTAINED BREATHING APPARATUS IF
OVER 1000 PPM.
Other Precautions: TOXIC VAPORS MAY EVOLVE ABOVE 600F. PROVIDE ADEQUATE
VENTILATION IF USED ABOVE THIS TEMPERATURE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONFLAMMABLE
Lower Limits: NOT GIVEN
Upper Limits: NOT GIVEN
Extinguishing Media: FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER SPRAY
Fire Fighting Procedures: FIRE FIGHTERS SHOULD WEAR SELF CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE GEAR. COOL TANKS AND CONTAINERS EXPOSED TO FIRE
WITH WATER.
Unusual Fire/Explosion Hazard: TOXIC FLUORINE GASES MAY EVOLVE IF HEATED ABOVE
600F.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED UNDER NORMAL CONDITIONS
Ventilation: EXHAUST VENTILATION SUFFICIENT TO KEEP AIRBORNE CONCENTRATIONS
BELOW RESPECTIVE TLV'S.
Other Protective Equipment: CHEMICAL RESISTANT CLOTHING AS NECESSARY TO PREVENT
SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE AVAILABLE.
Work Hygienic Practices: WASH HANDS THOROUGHLY WITH SOAP AND WATER BEFORE
EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health: DO NOT CONTAMINATE SMOKING MATERIALS OR FOOD
WITH PRODUCT.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V6
B.P. Text: NOT GIVEN
M.P/F.P Text: >500F,>260C
Decomp Text: NOT GIVEN
Vapor Pres: < 5
Vapor Density: NOT GIVEN
Spec Gravity: 1.30
Viscosity: NOT GIVEN
Evaporation Rate & Reference: NOT GIVEN
Solubility in Water: NIL
Appearance and Odor: YELLOW, FAINT ODOR
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: OXIDIZING MATERIALS CAN CAUSE A REACTION.
Hazardous Decomposition Products: FLUORINE PRODUCTS, SILICON DIOXIDE, CARBON
DIOXIDE, TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE. WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 64108
Product ID: CHRISTO-LUBE MCG 200
Review Date: 09/02/1998
Net Unit Weight: 5 GRAMS
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: TU
Container QTY: 0
Type Of Container: TUBE
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: CHRISTO-LUBE MCG 200
Cage: 0JRD3
Company Name: LUBRICATION TECHNOLOGY INC
Street: 310 MORTON ST
Zipcode: 45640
Label Required IND: Y
Date Of Label Review: 09/02/1998
Status Code: C
MFG Label NO: NONE
Label Date: 09/02/1998
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Health Hazard: None
Contact Hazard: None
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: STORE IN COOL WELL VENTILATED AREA OF LOW FIRE RISK.
AVOID BREATHING VAPORS. USE SELF-CONTAINED BREATHING APPARATUS IF OVER 1000
PPM. FIRST AID: INHALATION: REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIR ATION
IF BREATHING HAS STOPPED. EYES: FLUSH WITH WATER AND CONSULT PHYSICIAN. SKIN:
WASH WITH SOAP AND WATER. IF IRRITATION OCCURS, CALL PHYSICIAN. INGESTION:
DRINK MILK OR WATER. DO NOT INDUCE VOMITI NG. CALL PHYSICIAN.
=======================================================
| 1 | gloves_mandatory |
=======================================================
Product ID: TUFF N EASY ENAMEL SPRAY, 26001, 460 GLOSS BLUE
Cage: 90300
Box: 277
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 90300
Box: 277
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:LIQ & VAP MAY IRRIT EYES, SKIN & RESP TRACT.
MAY CAUSE CNS DEPRESS; HDCH, DIZZ, FATG, NAUS/UNCON. INHAL OF HIGH CONCS OF
VAP IS HARMFUL & MAY CAUSE HEART IRREGS. CHRONIC:REPORTS HAVE ASSOC PERM
BRAIN & NERV SYS DMG W/RPTD & PRLNG OCCUP OVEREXP TO SOLVS.
INTENTIONAL MISUSE BY DELIB CONCENTRATING &(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:INHALING VAPS MAY BE
HARMFUL/FATAL. ANIMAL STUDIES CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFTS
ON THE CNS, HEMATOPOIETIC TISS, BLOOD, KIDNEYS & LIVER, ASSOC W/ADMIN OF
ETHYLENE GLYCOL MONO BUTYL ETHER (EGBE). (EXTRACTED FROM DHHS (NIOSH)
PUBLICATION NO.90-118) (FP N).
Medical Cond Aggravated By Exposure: NONE KNOWN.
First Aid: EYES:FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. CONTACT
MD. SKIN:WASH W/SOAP & WATER. CONTACT MD IF IRRITATION DEVELOPS.
INHAL:REMOVE TO FRESH AIR. CONTACT MD IMMEDIATELY. INGEST:DO NOT I NDUCE
VOMITING. CONTACT MD OR REGIONAL POISON CONTROL CENTER IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: DIKE SPILL AREA. USE ABSORBENT MATERIAL OR SCRAPE UP
DRIED MATERIAL & PLACE INTO CONTAINERS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF ACCORDING TO FEDERAL, STATE & LOCAL
STANDARDS. USE ALL MATERIAL BEFORE DISPOSAL. IF UNABLE TO USE ALL MATERIAL
BEFORE DISPOSAL, RELIEVE PRESSURE IN CONTAINER UNTIL IT EQUALS EXTERNAL
PRESSU RE.
Handling And Storage Precautions: STORE AWAY FROM CAUSTICS & OXIDIZERS.
KEEP OUT OF REACH OF CHILDREN. DO NOT STORE AT TEMPERATURES ABOVE 120F.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NON-FLAMMABLE
Extinguishing Media: FOAM, CARBON DIOXIDE OR DRY CHEMICALS.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). COOL EXPOSED CONTAINERS W/WATER.
Unusual Fire/Explosion Hazard: CONTAINERS MAY EXPLODE IF EXPOSED TO EXTREME
HEAT. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS & OPEN FLAMES. DO
NOT PUT IN CONTACT W/OXIDIZING MATERIALS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN (FP N). NOT REQUIRED UNDER NORMAL USAGE & W/ADEQUATE VENTILATION.
SEE VENTILATION SECTION.
Ventilation: PROVIDE SUFFICIENT MECH VENT (LOC/GEN EXHST) TO MAINTAIN EXPOS
BELOW PEL & TLV. VAPS ARE HVR/AIR & WILL COLLECT (SUPDAT)
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDITIONAL INFORMATION (FP N). SPEC GRAV:0.8-0.88 (H*2O=1).
VENT:IN LOW AREAS. CHECK ALL LOW AREAS (BASEMENTS, SUMPS, ETC) BEFORE
ENTERING.
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Density: 1.59
Spec Gravity: SUPP DATA
Solubility in Water: MISCIBLE
Appearance and Odor: OPAQUE LIQUID W/SWEET SOLVENT ODOR.
Percent Volatiles by Volume: 90-94
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXCESSIVE HEAT & FREEZING.
Materials To Avoid: STRONG OXIDIZERS & CAUSTICS.
Hazardous Decomposition Products: NORMAL COMBUSTION PRODUCTS, I.E., CO*X, NO*X.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: TUFF N EASY ENAMEL SPRAY, 26001, 460 GLOSS BLUE
Cage: 90300
Company Name: DAP INC.
PO Box: 277
Zipcode: 45401-0277
Label Required IND: Y
Date Of Label Review: 08/06/1997
Status Code: C
Label Date: 08/06/1997
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:LIQUID AND VAPOR MAY IRRITATE EYES, SKIN AND
RESPIRATORY TRACT. MAY CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION; HEADACHE,
DIZZINESS, FATIGUE, NAUSEA OR UNCONSCIOUSNESS. INHALATION OF HIGH CONCENTRA
TIONS OF VAPOR IS HARMFUL AND MAY CAUSEHEART IRREGULARITIES. CHRONIC:ANIMAL
STUDIES CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFFECTS ON THE CENTRAL
NERVOUS SYSTEM, BLOOD-FORMING TISSUES, BLOOD, KIDNE YS AND LIVER, ASSOCIATED
WITH ADMINISTRATION OF 2-BUTOXYETHANOL (FP N). REPORTS HAVE ASSOC PERM BRAIN
& NERV SYS DMG W/RPTD & PRLNG OCCUP OVEREXP TO SOLVS. INTENTIONAL
MISUSE BY DELIB CONCENTRATING & INHALING VAPORS MAY BE HARMFUL OR FATAL.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AMMONIUM NITRATE - 1 - LOW DENSITY
CAGE:JO608
CAGE:JO608
CAGE:6R300
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM NITRATE
CAS:6484-52-2
RTECS #:BR9050000
Fraction by Wt: 98%,MIN
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPRIETARY ORGANIC ADDITIVES (CAS NUMBERS: 61788-45-2,
64742-52-5, 9084-06-4, 25155-30-0)
Fraction by Wt: .25%,MAX
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: .25%,MAX
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION- SLIGHT IRRITANT.
INGESTION- IRRITATION. SKIN- SLIGHT IRRITANT. EYES- IRRITATION.
Effects of Overexposure:INGESTION- MAY CAUSE CYANOSIS, NAUSEA, VERTIGO,
VOMITING, ABDOMINAL PAIN, AND RAPID HEART BEAT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES- IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES. IF
IRRITATION PERSISTS, GET PROMPT MEDICAL ATTENTION.SKIN- WASH WITH
MILD SOAP AND WATER FOR 15 MINUTES. INHALATION- PROVIDE FRESH AIR
AND GET MED ICAL ATTENTION IF DISCOMFORT PERSISTS.INGESTION- IF
CONSCIOUS, GIVE LARGE AMOUNTS OF WATER AND INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Extinguishing Media:FLOOD MELTED AND BURNING AMMONIUM NITRATE WITH
LARGE VOLUMES OF STRAIGHT STREAM WATER APPLICATION.
Fire Fighting Procedures:DO NOT SMOTHER FIRE. DO NOT ADD STEAM, DRY
CHEMICAL, OR CARBON DIOXIDE SMOTHERING APPLICATIONS.
Unusual Fire/Explosion Hazard:DO NOT USE SALT WATER. FIGHT FIRE FROM A
PROTECTED LOCATION AS STEAM ERUPTIONS ARE COMMON AND AMMOUNIUM
NITRATE SPLASHES ARE POSSIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT CONTAMINATION WITH COMBUSTIBLES AND
KEEP AWAY FROM HEAT. IF UNCONTAMINATED, RECOVER AND REUSE AS
PRODUCT. MAINTAIN ADEQUATE VENTILATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MINIMIZE CONTACT WITH SKIN AND EYES.
STORE IN COOL, WELL-VENTILATED AREA AWAY FROM COMBUSTIBLE
MATERIALS.
Other Precautions:DO NOT STORE IF CONTAMINATED WITH ORGANICS. BAGGED
AMMONIUM NITRATE IS SUBJECT TO STORAGE, STACKING AND QUANTITY
REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH-APPROVED RESPIRATOR IS RECOMMENDED WHEN
TLV IS EXCEEDED.
Ventilation:PROVIDE VENTILATION FOR NUISANCE DUST PROTECTION IN ORDER
TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:UNLESS SKIN IRRITATION DEVELOPS, NO
RECOMMENDATIONS.
Work Hygienic Practices:WASH THOROUGHLY AFTER CONTACT WITH THIS
PRODUCT.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:D1
Solubility in Water:0.66%
Appearance and Odor:WHITE, GRANULE PRILL, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WOOD CHIPS, ORGANIC MATERIALS, SULFUR, CHLORIDES, PHOSPHORUS, ACIDS,
FLAMMABLE AND COMBUSTIBLE LIQUIDS, AND CHARCOALS.
Stability Condition to Avoid:AVOID CONTAMINATION WITH OXIDIZABLE
MATERIAL.
Hazardous Decomposition Products:NITROGEN OXIDE GASES EMITTED ON
DECOMPOSITION ARE TOXIC. DECOMPOSES TO AMMONIA, NITRIC ACID, AND
NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PURELL INSTANT HAND SANITIZER, 9656FS
Preparer's Name:DONALD H SINNER
CAGE:02905
CAGE:02905
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL (ETHANOL); (DENATURATED ALCOHOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 40-70%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: EXPOSURE TO >1000
PPM MAY CAUSE HEADACHE, DROWSINESS, LASSITUDE AND LOSS OF APPETITE.
EYES: LIQUID OR VAPOR MAY CAUSE IRRITATION. SKIN: MAY CAUSE
IRRITATION AFTER PROLONGED CONTACTAND EXCESSIVE OVEREXPOSURE.
INGESTION: MAY CAUSE DEPRESSION OF CNS, NAUSEA, VOMITING AND/OR
DIARRHEA.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION
AND GET MEDICAL ATTENTION IF NECESSARY. EYES: IMMEDIATELY FLUSH
WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. CONTACT MD OR POISON
CONTROL CENTER. INGESTION: DRINK WATER OR MILD TO DILUTE. CONTACT
MD OR POISON CONTROL CENTER FOR SYMPTOMATIC TREATMENT. SKIN: FLUSH
WITH COPIOUS AMOUNTS OF WATER. SEE MD .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:74.0F,23.3C
Lower Limits:3%
Upper Limits:19%
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CARBON DIOXIDE, DRY
CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. VENTILATE THE
AREA. ABSORB ONTO INERT MEDIAN AND COLLECT IN AN APPROVED
CONTAINER. CLEAN AREA BY FLUSHING WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AN AMBIENT CONDITION. AVOID HIGH
TEMPERATURES AND IGNITION SOURCES.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DO NOT TAKE
INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. USE NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:ROUTINE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175F,79C
Vapor Pres:40
Vapor Density:1.6
Spec Gravity:0.90 (H*2O=1)
pH:>7.5
Evaporation Rate & Reference:>1 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID, CITRUS FRAGRANCE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS AS A FLAMMABLE WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:724-102 724-112
CAGE:0Y2E4
CAGE:0Y2E4
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *97-3*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 15%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 16%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL(IARC-GROUP 3) *97-3*
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 15%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:METHYL ETHYL KETONE, 2-BUTANONE *97-3*
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 15%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CELLOSOLVE (2-ETHOXYETHANOL), DOWANOL EE, ETHYLENE GLYCOL
ETHYL ETHER, OXITOL
CAS:110-80-5
RTECS #:KK8050000
Fraction by Wt: 20%
Other REC Limits:19 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:18 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:SKIN/EYES: FLUSH W/WATER. INHALATION: REMOVE TO FRESH AIR.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:28F
Lower Limits:1.3
Extinguishing Media:SMALL FIRES-CARBON DIOXIDE/DRY CHEM. LARGE
FIRES-FOAM
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS FOR
FIREMAN.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO HEAT MAY
EXPLODE
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION; HOT SURFACES &
ELECTRICAL STATIC/FRICTIONAL SPARKS. AVOID BREATHING VAPORS. REMOVE
W/INERT ABSORBENT & NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE ABOVE 120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED FOR STORAGE OF NFPA CLASS ONE
FLAMMABLE/COMBUSTIBLE.
Other Precautions:CONTAINERS SHOULD BE GROUNDED WHEN POURING. AVOID
FREE FALL OF LIQUID IN EXCESS OF A FEW INCHES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR/AIR SUPPLIED
RESPIRATOR.
Ventilation:PROVIDE GENERAL DILUTION/LOCAL EXHAUST AS NECESSARY
Supplemental Safety and Health
COMPONENT II. RESPIRATOR USE BASED ON CHEM. CONC. AND CONDITIONS OF USE
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:174-280F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:84.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FIRE, HEAT & HOT SURFACES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/LOCAL,STATE,AND FEDERAL
REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:6603067 NKH-1-RD1
Preparer's Name:S HEALY
CAGE:FO645
CAGE:FO645
CAGE:6Z677
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM AZIDE, AZIDE *96-4*
CAS:26628-22-8
RTECS #:VY8050000
Other REC Limits:0.1 PPM
ACGIH TLV:C 0.29 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL IRRITATION. SKIN:
IRRITATION, ABSORPTION, ALLERGIC REACTION. EYES: IRRITATIONS,
CONJUNCTIVITIS. INGESTION: BRONCHIAL IRRITATION, RESPIRATORY
IRRITATION, RESPIRATORY FAILURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, FAINTNESS,
NAUSEA, LOW BLOOD PRESSURE, BLURRED VISION, SHORTNESS OF BREATH,
COLLAPSE, BRONCHITIS, PALPITATION, WEAKNESS & UNSTEADINESS, COMA,
CONVULSIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE CPR.
IF BREATHING IS DIFFICULT GIVE OXYGEN. SKIN: WASH OFF THOROUGHLY
FOR 15 MINS. EYES: RINSE THOROUGHLY W/WATER & GIVE PLENTY OF WATER
TO DRIN K. INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICALS SUCH AS AN SODIUM CARBONATE/SAND.
Fire Fighting Procedures:BURNING SODIUM AZIDE WILL EXPLODE IF WATER IS
USED AS AN EXTINGUISHING MEDIA. SCBA MUST BE WORN.
Unusual Fire/Explosion Hazard:MAY EXPLODE & RELEASE TOXIC FUMES UPON
HEATING. DON'T ALLOW TO CONTACT METALS AT HIGH TEMPS.
(SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE W/RUNNING WATER BEFORE DISCHARGE.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM METALS & ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:GENERAL/LOCAL EXHAUST TO MEET TLV REQUIREMENTS
Other Protective Equipment:ADEQUATE LABORATORY ATTIRE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: FORMS HIGHLY SENSITIVE EXPLOSIVE COMPOUNDS W/HEAVY
METALS SUCH AS LEAD, SILVER & COPPER. WHEN HEATED TO 662F IT
DECOMPOSES EXOTHERMICALLY, BURNING W/A VERY HOT FLAME & PRODUCING N
ITROGEN & MOLTEN SODIUM.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:527F
Spec Gravity:1.85
Solubility in Water:40.16
Appearance and Odor:WHITE-COLORLESS CRYSTALS/POWDER, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS, ACIDS, ACID CHLORIDES & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:NITROGEN OXIDES, HYDRAZOIC ACID
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SILVER SLICK MS
CAGE:EO762
CAGE:8C233
CAGE:EO762
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
Fraction by Wt: 90%
OSHA PEL:100 PPM
Ingred Name:ALUMINUM
RTECS #:BO0330000
Fraction by Wt: 65%
ACGIH TLV:10 MG/CUM
===================== Hazards Identification =====================
Effects of Overexposure:HEADACHE, DIZZINESS, NAUSEA AND LOSS OF
CONSCIOUSNESS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE VICTIM TO FRESH AIR/PROVIDE OXYGEN IF
BREATHING IS DIFFICULT. EYES: FLUSH W/WATER. SKIN: WASH WITH
SOAP/WATER. REMOVE CONTAMINATED CLOTHING/DON'T USE UNTIL LAUNDERED.
INGESTION: DON 'T INDUCE VOMITING. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:110F (TCC)
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:COOL FIRE EXPOSED CONTAINERS SURROUNDING
EQUIPMENT/WATER.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SHOVEL UP AND PLACE IN DRUM FOR PROPER
DISPOSAL.
_
_
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT/SPARKS/FLAME. KEEP
CONTAINER CLOSED WHEN NOT IN USE. STORE AWAY FROM OXIDING MATERIALS
IN A COOL/DRY PLACE W/VENTILATION.
Other Precautions:WASH UP WITH SOAP AND WATER BEFORE EATING, DRINKING,
SMOKING OR USING TOILET FACILITIES. LAUNDER CONTAMINATED CLOTHING
BEFORREUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED RESPIRATOR AS REQUIRED TO
PREVENT OVER EXPOSURE
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO KEEP BELOW TLV
Other Protective Equipment:USUALLY NOT NEEDED
Supplemental Safety and Health
MSDS DATED: 20 NOV 1985.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:315-393F
Vapor Pres:0.3
Vapor Density:4.8
Spec Gravity:0.78
Evaporation Rate & Reference:(BU AC = 1) 0.07
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SILVER MOBILE LIQUID - TYPICAL HYDROCARBON ODOR
Percent Volatiles by Volume:96%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
Stability Condition to Avoid:AVOID HEAT, OPEN FLAMES
Hazardous Decomposition Products:CO/CO2/UNIDENTIFIED ORGANICS MAY BE
FORMED DURING COMBUSTION
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A FACILITY APPROVED UNDER RCRA
REGULATIONS FOR HAZARDOUS WASTE. DRUMS MUST BE TIGHTLY SEALED AND
PROPERLY LABELED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:51094 MOLY-50
Preparer's Name:CATHY GRIFFITH
CAGE:GO402
CAGE:GO402
CAGE:73165
============= Composition/Information on Ingredients =============
Ingred Name:SILICON DIOXIDE, CRYSTALLINE QUARTZ, SAND (ANIMAL CARC,
SUSPECTED HUMAN CARC IARC-GROUP 2A; SUSPECTED CARC NTP) *95-1*
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0.1%
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:0.1 MG/CUM RESP DUST
ACGIH TLV:0.1 MG/CUM RESP DUST
Ingred Name:PETROLATUM
Ingred Name:MOLYBDENUM DISULFIDE
CAS:1317-33-5
RTECS #:QA4697000
Fraction by Wt: >3%
OSHA PEL:15 MG/CUM AS (MO)
ACGIH TLV:10 MG/CUM AS (MO)
Ingred Name:SILICA, AMORPHOUS FUMED (IARC, GROUP 3) *95-1*
CAS:112945-52-5
RTECS #:VV7310000
OSHA PEL:0.1 MG/CUM
ACGIH TLV:0.1 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF INHALED/SWALLOWED. ELEVATED
TEMPERATURES MAY CAUSE IRRITATION OF THE EYES & RESPIRATORY TRACT.
SKIN/EYES: MECHANICAL IRRITANT. MAY CAUSE SKIN ABRASION. FREE
RESPIRABLE SILICA MAY CAUSE SILI COSIS/OTHER SERIOUS DELAYED LUNG
INJURY.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, TEARING, REDNESS, NAUSEA, VOMITING
Medical Cond Aggravated by Exposure:PRE-EXISTING PULMONARY &
DERMATOLOGICAL DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER. SKIN: WASH W/SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DON'T INDUCE
VOMITING. GIVE A GLASS OF WATER/MILK. NEVER GIVE ANYTHING BY MOUTH
IF UNC ONSCIOUS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>200F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE NIOSH APPROVED SELF CONTAINED BREATHING
APPARATUS & FULL PROTECTIVE CLOTHING. USE WATER TO COOL EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:WATER STREAM DIRECTED INTO FIRE MAY CAUSE
FROTHING. CLOSED CONTAINERS MAY RUPTURE/EXPLODE WHEN EXPOSED TO
EXTREME HEAT. TOXIC GASES/FUMES MAY BE GENERATED.
================== Accidental Release Measures ==================
Spill Release Procedures:RECLAIM CLEAN MATERIAL. MATERIAL SHOULD BE
SWEPT/SHOVELED INTO APPROPRIATE WASTE CONTAINER & DISPOSED OF.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT. KEEP OUT OF
REACH OF CHILDREN. FOR INDUSTRIAL USE ONLY. DON'T REUSE EMPTY
CONTAINERS W/OUT COMMERCIAL CLEAN/RECONDITION.
Other Precautions:AVOID PROLONGED/REPEATED CONTACT W/SKIN. DON'T TAKE
INTERNALLY. FOLLOW ALL PRECAUTIONS EVEN AFTER CONTAINER IS EMPTIED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED BUT IF LEVELS EXCEED
TLV/PEL/IF EFFECTS OCCUR, USE NIOSH APPROVED DUST/MIST RESPIRATOR.
Ventilation:GENERAL VENTILATION USUALLY ADEQUATE
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Work Hygienic Practices:FOLLOW GENERAL INDUSTRIAL SAFETY PRACTICES
DURING USE. WASH HANDS BEFORE EATING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:>1
Spec Gravity:1.3969
Evaporation Rate & Reference:SLOWER THAN BU ACETATE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY/BLACK PASTE W/MILD OIL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:OXIDES OF CARBON, VARIOUS HYDROCARBONS
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION PREFERRED/DISPOSE OF IN ACCORDANCE
W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NITROGEN
CAGE:03670
CAGE:03670
============= Composition/Information on Ingredients =============
Ingred Name:NITROGEN
CAS:7727-37-9
RTECS #:QW9700000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:ASPHYXIANT; 9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT APPLICABLE.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE-AVOID CONTACT WITH LIQUEFIED FORM
OF NITROGEN. CAN PRODUCE CHILLING SENSATIONS & DISCOMFORT, ALSO
FROSTBITE. SKIN-EVAPORATION OF LIQUID FROM SKIN CAN PRODUCE
CHILLING SENSATION. FROSTBITE CAN OCCU R. INHALATION-IN HIGH
CONCENTRATIONS, SIMPLE ASPHYXIANT. INGESTION-IS NOT LIKELY, SINCE
MATERIAL IS A GAS AT ROOM TEMP.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:ACUTE OVEREXPOSURE-DIZZINESS, HEADACHE,
TINNITUS, DIFFICULTY BREATHING, DROWSINESS, DEPENDING ON LENGTH OF
EXPOSURE AND CONCENTRATIONS. CHRONIC OVEREXPOSURE-COMPRESSED AIR
ILLNESS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYE-IMMEDIATELY FLUSH EYES WITH WATER FOR 15 MIN. GET MEDICAL
ATTENTION. TREAT FOR FROSTBITE IF NEEDED. SKIN-WASH MATERIAL OFF
SKIN WITH SOAP & WATER FOR 15 MIN. GET MEDICAL ATTENTION. TREAT FOR
FROST BITE IF NEEDED. INHALATION-REMOVE TO FRESH AIR. IF COUGH OR
OTHER RESPIRATORY SYMPTOMS OCCUR, CONSULT MEDICAL PERSONNEL.
INGESTION-IS NOT LIKELY TO OCCUR SINCE THIS MATERIAL IS GAS AT ROOM
TEMPERATURE
===================== Fire Fighting Measures =====================
Flash Point:NONE
Fire Fighting Procedures:THOUGH GAS CYLINDRES ARE EQUIPPED WITH
PRESSURE AND TEMPERATURE RELIEF DEVICES - REMOVE CYLINDERS FROM
FIRE OR HIGH TEMPERATURE TO AVOID DANGER OF RUPTURE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE TO OUTSIDE.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINERS IN A CLEAN, DRY
WELL-VENTILATED AREA AWAY FROM HEAT ABOVE 125F. STORE AS A
COMPRESSED GAS IN DOT APPROVED VESSELS.
Other Precautions:IF CYLINDER IS NOT ATTACHED TO A SYSTEM, IT MUST BE
SAFETY CLAPPED TO PROTECT AGAINST VIOLENT VESSEL MOVEMENT OR FORCE
OF ESCAPING GAS IF VALVE IS ACTUATED OR SEAL IS ACCIDENTALLY
PUNCTURED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NECESSARY IF CONTROLS ARE ADEQUATE.
IF EXPOSURE IS PROLONGED, A SELF-CONTAINED BREATHING APPARATUS IS
RECOMMENDED.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN CONFINED SPACE USE. GENERAL
MECHANICAL VENTILATION IS RECOMMENDED.
Other Protective Equipment:PROTECTIVE CLOTHING FOR CONTACT WITH LIQUID.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. USE PROPER CARE WHEN HANDLING AND STORING
CYLINDERS.
Supplemental Safety and Health
NITROGEN IS A GAS COMPRESSED UP TO 2400 PSI AT 70F.
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-320F,-196C
Vapor Density:0.98 AIR=1
Evaporation Rate & Reference:N/R, GAS AT ROOM TEMP.
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS GAS, WITH NO ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAN REACT VIOLENTLY WITH LITHIUM (LI), NEODYMIUM (ND) AND TITANIUM (TI)
UNDER PROPER CONDITIONS.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN COMPLIANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AQUA-FAS MASTIC WHITE/TROWEL, FOSTER 38-00
CAGE:FSTRP
CAGE:FSTRP
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID, VINYL ESTER; (VINYL ACETATE) (SARA 302/313)
(CERCLA) LD50 (ORAL RAT): 2920 MG/KG
CAS:108-05-4
RTECS #:AK0875000
Fraction by Wt: <0.5%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15, A3 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:FORMALDEHYDE (SARA 302/313) (CERCLA)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: <0.0081%
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM, A2
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ALUMINUM OXIDE (SARA 313)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 10-30%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 10-30%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SILICIC ACID, CALCIUM SALT; (CALCIUM SILICATE)
CAS:1344-95-2
RTECS #:VV9150000
Fraction by Wt: 5-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TITANIUM DIOXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1-5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CONT W/LIQ PROD MAY CAUSE
IRRIT. SKIN: PRLNG/RPTD CONT W/LIQ PROD MAY CAUSE IRRIT. INHAL:
EXPOS TO VAPS IN POORLY VENTD AREAS MAY CAUSE IRRIT OF NOSE, THROAT
& RESP TRACT. INGEST: NOT ANT IC RTE OF EXPOS. SML AMTS NOT ANTIC
TO BE HARMFUL. CHRONIC: OVEREXP TO VINYL ACETATE NOT EXPECTED TO
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:VINYL ACETATE: IARC MONO ON EVAL OF
CARCIN RISK OF CHEMS TO MAN, VOL 63, PG 443, 1995: GROUP 2B.
ANIMAL: NASAL CAVITIES.
Effects of Overexposure:HLTH HAZ: OCCUR DURING NORM HNDLG & USE OF THIS
PROD. VINYL ACETATE HAS BEEN SHOWN TO CAUSE IRRIT & CANCER IN INHAL
STUDIES W/LAB ANIMALS. TEST LEVELS OF 600 PPM CAUSED INCR IN TUMORS
IN RESP TRACT OF TEST ANIMALS. NO TUMORS WERE OBSERVED IN ANIMALS
EXPOSED AT 50 PPM/LOWER.
Medical Cond Aggravated by Exposure:NO KNOWN EFFECTS ON OTHER
ILLNESSES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMED W/WATER FOR AT LEAST 15 MIN. CONSULT MD IF
IRRIT PERSISTS. SKIN: WASH AFFECTED AREA W/SOAP & WATER. LAUNDER
CONTAM CLTHG BEFORE REUSE. INHAL: REMOVE SUBJECT TO FRESH AIR.
INGEST: IFPERS CAN SWALLOW, GIVE 1 GLASS OF WATER/MILK. DO NOT
INDUCE VOMIT. GET IMMED MED ATTN. NEVER GIVE ANYTHING BY MOUTH TO
AN UNCON PERS.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:NON-FLAMMABLE IN LIQUID STATE. USE WATER SPRAY,
FOAM, DRY CHEMICAL, OR CARBON DIOXIDE ON DRIED PRODUCT.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERE IS THE POSSIBILITY OF PRESSURE
BUILD-UP IN CLOSED CONTAINERS WHEN HEATED. WATER SPRAY MAY BE USED
TO COOL THE CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE IF NECESSARY, CONTAIN SPILL WITH INERT
ABSORBENT AND TRANSFER TO CONTAINERS FOR DISPOSAL. KEEP SPILLED
PRODUCT OUT OF SEWERS, WATERSHEDS OR WATER SYSTEMS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WEAR APPROPRIATE PROTECTIVE EQUIPMENT
WHEN WORKING WITH THIS PRODUCT. AVOID TEMPERATURE EXTREMES IN
STORAGE.
Other Precautions:CONSULT THE TECHNICAL DATA SHEET FOR SPECIFIC STORAGE
INSTRUCTIONS. PREVENT PROLONGED OR REPEATED CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR IF CONDITIONS WARRANT.
Ventilation:GENERAL DILUTION VENTILATION.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . USE PROTECTIVE CLOTHING.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>200F,>93C
Spec Gravity:1.39
VOC Pounds/Gallon:50
pH:9
Appearance and Odor:LIQUID, WITH MILD, SWEET ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:SOLIDIFY AND DISPOSE OF IN AN APPROVED LANDFILL.
CONSULT STATE, LOCAL, PROVINCIAL AND FEDERAL AUTHORITIES FOR MORE
RESTRICTIVE REQUIREMENTS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TB CARBOLFUCHSIN ZN 3313
Preparer's Name:ELLEN M BERNARD
CAGE:04487
CAGE:04487
============= Composition/Information on Ingredients =============
Ingred Name:CI. BASIC RED 9, MONOHYDROCHLORIDE, (IARC GROUP 2B,ANIMAL
SUFFICIENT), (NTP-SUSPECTED CARCINOGEN), *96-1*
CAS:569-61-9
RTECS #:CX9850100
Fraction by Wt: 0.17%
Other REC Limits:A2 CARCINOGEN
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 9.5%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:PHENOL (IARC CARC - GROUP 3) *96-1*
CAS:108-95-2
RTECS #:SJ3325000
Fraction by Wt: 5%
Other REC Limits:5 MG/CUM
OSHA PEL:19 MG/CUM
ACGIH TLV:19 MG/CUM (SKIN)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(MOUSE): 3600MG/KG ISOPROPANOL
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:WARNING: CAUSES IRRITATION.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:WARNING: CAUSES IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/PLENTY OF WATER FOR 15 MINS. INHALATION:
REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED, PREFERABLY MOUTH TO
MOUTH. OBTAIN MEDICAL ATTENTION IN ALL CASES.
================== Accidental Release Measures ==================
Spill Release Procedures:LARGE: WEAR DUST MASK/RESPIRATOR, HEAVY RUBBER
DISPOSAL. VENTILATE AREA. SMALL: WIPE UP W/A DAMP SPONGE/MOP, RINSE
DOWN DRAIN W/PLENTY O F WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN COOL, DRY PLACE.
Other Precautions:DON'T BREATHE. AVOID CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR DUST MASK/RESPIRATOR.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:LAB APRON
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:REDDISH-PURPLE SUSPENSION
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE/MIX THE MATERIAL W/A COMBUSTIBLE
SOLVENT & BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER
& SCRUBBER, IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:842 5704 T-855-01 DEVELOPER,PART F
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70 - 75%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:ACETIC ACID (CERCLA)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 10 - 15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SODIUM BROMIDE
CAS:7647-15-6
RTECS #:VZ3150000
Fraction by Wt: 10 - 15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYETHYLENE GLYCOL/POLYMERIC GLYCOL
CAS:25322-68-3
RTECS #:TQ3500000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- INHALATION:VAPORS MAY CAUSE RESPIRATORY TRACT
IRRITATION. EYES:CAUSES IRRITATION OR BURNS. VAPORS IRRITATING.
SKIN:CAUSES IRRITAATION. ORAL:HA RMFUL IF SWALLOWED. MAY CAUSE
GASTROINTESTINAL TRACT BURNS. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SEVERE IRRITATION, SEVERE BURNS, PAIN, TEARING,
COUGHING
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:IMMEDIATELY FLUSH WITH
WATER FOR AT LEAST 15 MINUTES. HOLD EYELIDS OPEN. CALL PHYSICIAN.
SKIN:FLUS H WITH WATER FOR 15 MINUTES WHILE REMOVING CONTAMINATED
CLOTHING. ORAL:DO NOT INDUCE VOMITING. IF CONSCIOUS, DRINK A GLASS
OF WATER. CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
Unusual Fire/Explosion Hazard:MAY FORM CORROSIVE MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENTS. VENTILATE AREA.
NEUTRALIZE WITH BAKING SODA. FLUSH TO SEWER WITH WATER IF ALLOWED.
OTHERWISE, ABSORB WITH VERMICULITE. PLACE IN A CONTAINER FOR
DISPOSAL. CLEAN SURFACE THOR OUGHLY. PREVENT RUNOFF FROM ENTERING
SEWERS.
Neutralizing Agent:SODIUM BICARBONATE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
AWAY FROM BASES.
Other Precautions:KEEP THIS AND ALL CHEMICALS OUT OF REACH OF CHILDREN.
THIS PRODUCT FOR INDUSTRIAL USE ONLY. AVOID BREATHING VAPORS OR
MISTS. DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. WASH THOROUGHLY
AFTER HANDLING. LAUNDER CONTAMINATED CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW TLV/PEL, A NIOSH-APPROVED ORGANIC VAPOR
RESPIRATOR MUST BE WORN. A PROGRAM SHOULD BE INSTITUTED TO ASSURE
COMPLIANCE WITH OSHA STA NDARD 29 CFR 1910.134.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
KEY1:C1. ECOLOGICAL INFORMATION: A MODERATE BIOCHEMICAL OXYGEN DEMAND,
A LOW POTENTIAL TO AFFECT AQUATIC ORGANISMS. AFTER DILUTION WITH
WATER, FOLLOWED BY WASTE TREATMENT, IT IS NOT EXPECTED TO CAUSE
ADVERSE ENVIRONMENTAL EFFECTS.
================== Physical/Chemical Properties ==================
HCC:C1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18 @ 68F
Vapor Density:0.6
Spec Gravity:1.109
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID
Percent Volatiles by Volume:85- 90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
HYDROBROMIC ACID
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL IS SUBJECT TO
FEDERAL, STATE OR LOCAL REGULATIONS. FLUSH TO SEWER WITH LARGE
AMOUNT OF WATER, IF ALLOWED. SINCE EMPTIED CONTAINERS RETAIN
PRODUCT RESIDUE, FOLLOW LABEL WARNINGS EVEN AFTER CONTAINER IS
EMPTIED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FLEXANE HIGH PERFORMANCE PUTTY RESIN, 15330
Kit Part:Y
CAGE:IO159
CAGE:16059
CAGE:IO159
============= Composition/Information on Ingredients =============
Ingred Name:BENZENE, 2,4-DIISOCYANATO-1-METHYL-;(2,4-TOLUENE
DIISOCYANATE (TDI))
CAS:584-84-9
RTECS #:CZ6300000
Fraction by Wt: 1-5%
OSHA PEL:C,0.02 PPM/0.02 STEL
ACGIH TLV:0.005PPM/0.02STEL;93
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ISOCYANIC ACID, METHYLENEDI-P-PHENYLENE
ESTER;(4,4'-DIPHENYLMETHANE DIISOCYANATE (MDI))
CAS:101-68-8
RTECS #:NQ9350000
Fraction by Wt: 1-5%
OSHA PEL:0.02 PPM,C
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POLYETHER PREPOLYMER;(POLYETHER PREPOLYMERS OF TID AND MDI)
CAS:9048-58-2
Fraction by Wt: >60%
Ingred Name:2-BUTANONE;(METHYL ETHYL KETONE (MEK))
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 10-30%
OSHA PEL:200 PPM;300 STEL
ACGIH TLV:200 PPM;300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:P-CRESOL, 2-6-DI-TERT-BUTYL-;(BUTYLATED HYDROXYTOLUENE
(BHT))
CAS:128-37-0
RTECS #:GO7875000
Fraction by Wt: 1-5%
ACGIH TLV:10 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL RAT) 870 MG/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:MAY CAUSE MODERATE TO SEVERE
IRRITATION. SKIN:MAY CAUSE LOCALIZED IRRITATION, SWELLING AND
DRYNESS OF SKIN. INHAL:MAY CAUSE IRRITATION OF THE RESPIRATORY
TRACT, HEADACHE, DIZZINESS, NAUSEA. INGEST:NO DATA WERE FOUND ON
ACUTE EFFECTS.
Explanation of Carcinogenicity:TDI:GROUP 2B (IARC), GROUP 2 (NTP).
Effects of Overexposure:CHRONIC:MAY PRODUCE SKIN AND RESPIRATORY
SENSITIZATION. TDI WAS FOUND CARCINOGENIC IN ANIMAL TESTS BY
INGESTION AND MAY BE CARCINOGENIC BY INHALATION.
Medical Cond Aggravated by Exposure:PEOPLE WITH BRONCHIAL
HYPERREACTIVITY OR ISOCYANATE HYPERSENSITIVITY WILL BE AFFECTED BY
CONCENTRATIONS BELOW TLV.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH CLEAN WATER FOR AT LEAST 15 MINUTES WHILE
GENTLY HOLDING EYELIDS OPEN. GET MD. SKIN:REMOVE CONTAMINATED
CLOTHING. WASH WITH GREEN/PLAIN SOAP & WATER. INHAL:MOVE TO FRESH
AIR; GIVE ARTIF ICIAL RESPIRATION/O2 AS NEEDED; GET MD.INGEST:IF
CONSCIOUS, INDUCE VOMITING WITH WARM SALT WATER (1 TBSP PER CUP).
FOLLOW WITH LOTS OF MILK; GET MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:24.0F,-4.4C
Lower Limits:1.4%
Upper Limits:11.5%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY PRODUCE IRRITATING GASES OR MISTS
FROM DECOMPOSITION OR COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT SKIN & EYE CONTACT. ABSORB SPILLAGE ON
INERT MATERIAL; TRANSFER TO AN OPEN CONTAINER IN A WELL VENTILATED
AREA. TREAT WITH DILUTE AMMONIA FOR 24 HOURS IN OPEN CONTAINER.
WASH SPILL AREA WITH S TRONG DETERGENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. STORE
CONTAINERS CLOSED. KEEP AWAY FROM INTENSE HEAT, SPARKS AND OPEN
FLAME.
Other Precautions:KEEP MOISTURE OUT OF CONTAINERS-IT WILL CAUSE RELEASE
OF CARBON DIOXIDE WHICH COULD BURST A CLOSED CONTAINER. KEEP HANDS
AWAY FROM EYES WHEN HANDLING THIS MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL EQUIPMENT NEEDED IF VENTILATION IS
ADEQUATE. IF NOT, USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:DESIGN ADEQ VENT TO KEEP VAP CONC BELOW TLV, GEN MECH VENT
IS NORMALLY ADEQ FOR OCCASIONAL USE IN OPEN AREAS;(SUPP DATA)
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO PREVENT
SKIN CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER USING THIS MATERIAL,
ESPECIALLY BEFORE EATING OR SMOKING.
Supplemental Safety and Health
KEY1: F5. THIS ENTRY DESCRIBES PART A OF A TWO PART KIT. SEE THIS SAME
NSN, P/N IND B, FOR PART B DATA. LOCAL EXHAUST IS RECOMMENDED FOR
REPEATED USE OR IN CONFINED AREAS.
================== Physical/Chemical Properties ==================
HCC:F5
Boiling Pt:B.P. Text:152F,67C
Vapor Pres:65 @ 68F
Vapor Density:3.94
Spec Gravity:0.99
pH:5
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:SLIGHT;REACTS
Appearance and Odor:CLEAR, VISCOUS LIQUID WITH SWEET ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MOISTURE (REACTS SLOWLY, RELEASING CO2); ALCOHOLS, AMINES, BASES,
STRONG OXIDIZERS.
Stability Condition to Avoid:HIGH HEAT AND FLAME.
Hazardous Decomposition Products:ISOCYANATES AND AMINES; MORE COMPLETE
COMBUSTION WILL PRODUCE COX, NOX AND TRACES OF HCN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD TREATED WASTE IN A FACILITY COMPLYING
WITH STATE AND LOCAL REGULATIONS FOR ORGANIC AMINES AND AMINE
ADDUCTS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-380-1755
Product ID: SO-SURE BLUE 35260, 682-856
Cage: 0FTT5
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0FTT5
=======================================================
Contractor Summary
=======================================================
Cage: 0FTT5
=======================================================
Item Description Information
=======================================================
Item Name: PAINT,OIL
Specification Number: TT-P-2118D
Type/Grade/Class: TYPE 3
Type of Container: METAL
=======================================================
Ingredients
=======================================================
Cas: 64475-85-0
RTECS #: PY8240000
% Wt: <40.34
Other REC Limits: NONE RECOMME
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM
------------------------------
Cas: 1330-20-7
RTECS #: ZE2100000
% Wt: <1.70
Other REC Limits: NONE RECOMME
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 100 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
RTECS #: 9999999VO
Other REC Limits: NONE RECOMME
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CONCENTRATING & INHALING CONTENTS MAY BE
HARMFUL/FATAL. REPEATED/PROLONGED OVEREXPOSURE:PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE. IN CONFINED AREAS, VAPOR IN HIGH CONCENTRATIONS ARE
ANESTHETIC. SKIN & RESPIRATORY TRACT IRRITATION. LIGHT
HEADEDNESS,STAGGERING,GIDDINESS,NAUSEA. SEVERE EYE IRRITATION. HARMFUL IF
SWALLOWED.
Signs And Symptions Of Overexposure: IRRITATION TO EYES, THROAT, AND
RESPIRATORY TRACT. MAY CAUSE HEADACHES, NAUSEA, AND VOMITING.
Medical Cond Aggravated By Exposure: RESPIRATORY AILMENTS.
First Aid: FOR CONTACT WITH SKIN OR CLOTHES, WASH WITH SOAP AND WATER; WASH
CLOTHES BEFORE REUSE. FOR CONTACT WITH EYES, FLUSH WITH WATER AT LEAST 15
MINUTES & CONTACT PHYSICIAN/OPHTHALMOLOGIST IMMEDIATELY. IF I NGESTED, DO
NOT INDUCE VOMITING. GET IMMEDIATE MED AID. IF INHALED, REMOVE TO FRESH AIR
& GIVE ARTIFICIAL RESPIRATION IF NECESSARY & GET MED AID. NEVER GIVE
ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION AND VENTILATE AREA.
MOP SPILLS WITH INERT ABSORBENT. AVOID BREATHING VAPORS.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH APPLICABLE FEDERAL,
STATE, & LOCAL REGULATIONS.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT
WITH EYES OR SKIN. AVOID CONTACT WITH EYES AND SKIN. USE WITH GOOD
VENTILATION.
Other Precautions: READ ENTIRE LABEL BEFORE USING. FOLLOW ALL LABEL DIRECTIONS.
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND INHALING OR SWALLOWING
CONTENTS MAY BE HARMFUL OR FATAL.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 102F,39C
Autoignition Temp Text: 874 F
Lower Limits: 1.0
Upper Limits: 5.3
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY.
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE, USE TO KEEP FIRE EXPOSED
CONTAINER COOL. WEAR SCBA. USE SHIELDING TO PROTECT PERSONNEL AGAINST
BURSTING, RUPTURING, VENTING OF CNTNRS.
Unusual Fire/Explosion Hazard: DO NOT SPRAY NEAR OPEN FLAME.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
ALWAYS MAINTAIN TLV.
Ventilation: LOCAL EXHAUST: PREFERRED. MECHANICAL (GENERAL): ACCEPTABLE AT
POINT OF MIST OF SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN. EYE WASH
STATION.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DO NOT EAT, DRINK, OR SMOKE
WHILE USING PRODUCT.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: F4
B.P. Text: 270 TO 400F
Vapor Pres: 2.6 @ 68F
Vapor Density: >1.0
Spec Gravity: 1.026 (WATER=1)
Solubility in Water: INSOLUBLE
Appearance and Odor: BLUE/PAINT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Hazardous Decomposition Products: CARBON MONOXIDE AND OTHER TOXIC AND NOXIC
FUMES.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 131099
Product ID: SO-SURE BLUE 35260, 682-856
Review Date: 03/24/1994
Net Unit Weight: 8.55 LBS
Multiple KIT Number: 0
Review IND: Y
Type Of Container: METAL
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: LFE
DOT Proper Shipping Name: PAINT
DOT PSN Modifier: INCLUDING PAINT, LACQUER, ENAMEL, STAIN, SHELLAC SOLUTIONS,
VARNISH, POLISH, LIQUID FILLER, AND LIQUID LACQUER BASE
Hazard Class: 3
UN ID Num: UN1263
DOT Packaging Group: III
Label: FLAMMABLE LIQUID
Special Provision: B1,B52,T7,T30
Packaging Exception: 150
Non Bulk Pack: 173
Bulk Pack: 242
Max Qty Pass: 60 L
Max Qty Cargo: 220 L
Vessel Stow Req: E,B,A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: LCT
IMO Proper Shipping Name: PAINT OR PAINT RELATED MATERIAL
IMO PSN Modifier: (INCLUDING PAINT, LACQUER, ENAMEL, STAIN, SHELLAC SOLUTIONS,
VARNISH, POLISH, LIQUID FILLER AND LIQUID LACQUER BASE) OR (INCLUDING PAINT
THINNING OR REDUCING COMPOUND) o
IMDG Page Number: 3372
UN Number: 1263
UN Hazard Class: 3.3
IMO Packaging Group: III
Subsidiary Risk Label: -
EMS Number: 3-05
MED First Aid Guide NUM: 310
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: SXH
IATA UN ID Num: 1263
IATA Proper Shipping Name: PAINT
IATA PSN Modifier: (INCLUDING PAINT, LACQUER, ENAMEL, STAIN, SHELLAC, VARNISH,
POLISH, LIQUID FILLER AND LIQUID LACQUER BASE)
IATA UN Class: 3
IATA Label: FLAMMABLE LIQUID
UN Packing Group: III
Packing Note Passenger: 309
Max Quant Pass: 60L
Max Quant Cargo: 220L
Packaging Note Cargo: 310
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: SXH
AFI Proper Shipping Name: PAINT OR PAINT RELATED MATERIAL
AFI PSN Modifier: (INCLUDING PAINT, LACQUER, ENAMEL, STAIN, SHELLAC SOLUTIONS,
VARNISH, POLISH, LIQUID FILLER AND LIQUID LACQUER BASE) OR (INCLUDIN PAINT
THINNING OR REDUCING COMPOUNDS)
AFI Hazard Class: 3
AFI UN ID NUM: UN1263
AFI Packing Group: III
Special Provisions: P5
Back Pack Reference: A7.3
=======================================================
HAZCOM Label
=======================================================
Product ID: SO-SURE BLUE 35260, 682-856
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Street: 8833 FLEISCHER PLACE
Zipcode: 63134
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: CONCENTRATING & INHALING CONTENTS MAY BE
HARMFUL/FATAL. REPEATED/PROLONGED OVEREXPOSURE:PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE. IN CONFINED AREAS, VAPOR IN HIGH CONCENTRATIONS ARE
ANESTHETIC. SKIN & RESPIRATORY TRACT IRRITATION. LIGHT
HEADEDNESS,STAGGERING,GIDDINESS,NAUSEA. SEVERE EYE IRRITATION. HARMFUL IF
SWALLOWED.IRRITATION TO EYES, THROAT, AND RESPIRATORY TRACT. MAY CAUSE
HEADACHES, NAUSEA, AND VOMITING.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DER 736 EPOXY RESIN, 19373
CAGE:EO044
CAGE:96717
CAGE:EO044
============= Composition/Information on Ingredients =============
Ingred Name:EPICHLOROHYDRIN-POLYGLYCOL REACTION PRODUCT
CAS:41638-13-5
Fraction by Wt: 100%
Ingred Name:SUPP DATA: LARGE SPILLS: EVACUATE UPWIND OF SPILLS AND
CONTAIN WITH DIKE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) > 2000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: MAY CAUSE SLIGHT IRRIT. CORNEAL
INJURY IS UNLIKELY. SKIN: PRLNG EXP MAY CAUSE SKIN IRRIT. RPTD EXP
MAY CAUSE SKIN BURNS. MAY CAUSE MORE SEVERE RESPONSE IF CONFINED TO
SKIN/SKIN IS ABRADED (SCRATC HED/CUT). MAY CAUSE ALLERGIC SKIN RXN
IN SUSCEPTIBLE INDIV. SKIN ABSORP: A SINGLE PRLNG EXP IS
UNLIKELY(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: TO RESULT IN MATL BEING ABSORBED THRU
SKIN IN HARMFUL AMTS. DERMAL LD50 HAS NOT BEEN DETERMINED. INGEST:
SINGLE DOSE ORAL TOX IS LOW. AMTS INGESTED INCIDENTAL TO INDUSTRIAL
HNDLG ARE NOT LIK ELY TO CAUSE INJURY; HOWEVER INGEST OF LRG AMTS
MAY CAUSE INJURY. INHAL: ELEVATED TEMPS MAY GENERATE VAPOR (SUPP
DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:IRRIGATE IMMED W/H*2O FOR AT LEAST 15 MIN. SKIN: WASH OFF
IN FLOWING H*2O/SHOWER. INGEST:NO ADVERSE EFTS ANTIC BY THIS ROUTE
OF EXP INCIDENTAL TO PROPER INDUS HNDLG. INHAL:REMOVE TO FRESH AIR
IF E FTS OCCUR. CONSULT MD. NOTE TO MD: IF BURN IS PRESENT, TREAT
AS ANY THERMAL BURN, AFTER DECONTAM. NO SPEC ANTIDOTE. SUPPORTIVE
CARE. TRTMT BASED ON JUDGEMENT OF MD IN RESPONSE TO RXN OF THE
PATIENT.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:320F,160C
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP IN ABSORB MATL SUCH AS SAND & COLLECT
IN SUITABLE CNTNRS. RESIDUAL RESIN MAY BE REMOVED USING STEAM/HOT
SOAPY WATER. USE OF METHYLENE CHLORIDE/OTHER SOLV IN CLEANUP POSES
A DISTINCT HAZ & THER EFORE SHOULD BE AVOIDED. KEEP SPARK (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE EXCEPT NORMAL HANDLING CARE.
PRACTICE GOOD CAUTION AND PERSONAL CLEANLINESS TO AVOID EYE & SKIN
CONTACT. AVOID BREATHING VAPOR IF GENERATED.
Other Precautions:FOR MORE COMPLETE INFORMATION, SEE DOW BULLETIN ON
"DOW EPOXY RESINS SAFE HANDLING AND STORAGE GUIDE."
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO RESPIRATORY PROTECTION SHOULD BE NEEDED. IF
RESPIRATORY IRRITATION IS EXPERIENCED, USE A NIOSH/MSHA APPROVED
AIR-PURIFYING RESPIRATOR.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT FOR MOST
CONDITIONS.
Other Protective Equipment:PROT CLTHG IMPERVIOUS TO THIS MATL.
SELECTION OF SPEC ITEMS SUCH AS BOOTS, APRON, OR FULL-BODY SUIT
DEPENDS ON OPER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PROD:THERMAL DECOMP PROD OF EPOXY RESINS THEREFORE SHOULD BE
TREATED AS POTENTIALLY HAZ SUBSTANCES, & APPROP PREC SHOULD BE
TAKEN. EFTS OF OVEREXP: LEVELS SUFFICIENT TO CAUSE IRRIT & OTHER
EFTS. SYSTEMIC & OTHER EFTS:RESULTS OF IN VITRO MUTAG TESTS HAVE
BEEN POS. SPILL PROC:PRODUCING EQUIP AWAY. (ING 2)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>437F,>225C
Vapor Pres:5.6 @20C
Spec Gravity:1.14
Solubility in Water:VERY SLIGHT
Appearance and Odor:NEAR WATER WHITE LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASE OR STRONG ACID.
Stability Condition to Avoid:NONE; BUT FOR MAXIMUM PRODUCT LIFE DO NOT
EXCEED 55 C (131F) DURING STORAGE.
Hazardous Decomposition Products:THE BY-PROD EXPECTED IN INCOMPLETE
PYROLYSIS/COMBUST OF EPOXY RESINS ARE MAINLY PHENOLICS, CO, HCL, &
H*2O. (SUPP DATA)
Conditions to Avoid Polymerization:MASSES >1 LB OF PROD PLUS AN
ALIPHATIC AMINE WILL CAUSE IRREVERSIBLE POLYMERIZATION WITH
CONSIDERABLE HEAT BUILDUP.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN ADEQUATE INCINERATOR OR BURY IN
LANDFILL. DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & NATURAL/SYNTHETIC RUBBER & NICKEL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FLUX-OFF PLUS, ES795
Preparer's Name:M WATKINS
CAGE:2M589
CAGE:21267
CAGE:2M589
============= Composition/Information on Ingredients =============
Ingred Name:ING 8:EXPOSED TO STRONG ACID MANUFACTURE PROCESS. BY-PRODS
FROM THIS PARTICULAR MFG PROCESS (I.E.ISOPROPYL (SEE ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:OILS, DIISOPROPYL SULFATE,ETC.)ARE THOUGHT TO BE
CANCER CAUSING AGENTS, RATHER THAN ISOPROPYL ALCOHOL (SEE ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:PRODUCED BY PROCESS. OSHA REGULATED & CONSIDERED AN
OSHA AIR CONTAMINANT.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:NOTE TO MD:BECAUSE OF POSS RISK OF ELICITING
CARD DYSRYTHMIAS, CATECHOLINAMINE DRUGS, SUCH (SEE ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:AS EPINEPHRINE, SHOULD BE USED ONLY AS A LAST RESORT
IN LIFE THREATENING EMERGENCIES.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:SECTION 313 OF THE EMERGENCY PLANNING &
COMMUNITY RIGHT-TO-KNOW ACT OF 1986 (40 CFR 372).
RTECS #:9999999ZZ
Ingred Name:ING 7:CARCINOGEN BY IARC & NTP.THESE LISTINGS REFER TO
HIGHER INCIDENCE OF CERTAIN TYPES OF TUMORS IN WORKERS(SEE ING 9)
RTECS #:9999999ZZ
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 91.2%
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
Ingred Name:SUPP DATA:SENSITIZATION OF MYOCARDIUM TO EPINEPHRINE IN LAB
ANIMALS & COULD HAVE A SIMILAR EFFECT IN HUMANS. (SEE ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:ADRENOMIMETICS (E.G.,EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS (SEE ING
7)
RTECS #:9999999ZZ
Ingred Name:ING 6:ACUTELY OR CHRONICALLY EXPOSED TO CHLOROCARBONS OR
CFC'S . ISOPROPYL ALCOHOL IS LISTED AS A (SEE ING 8)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:VAP IS HEAVIER THAN AIR & CAN
CAUSE SUFFOCATION BY REDUCING O2 AVAIL FOR BRTHG. EYE:LIQ CNTCT CAN
CAUSE EXTREME DISCOMFORT. PROD CONTAINS ISOPROPYL & ETHYL ALCOHOLS
WHICH ARE EYE IRRITANTS. INGE ST:SWALLOWING LIQ CAN RESULT IN IRRIT
OF MOUTH, THROAT & GI TRACT. SKIN:RPTD LIQ CNTCT CAN CAUSE
DEFATTING. (SUPP DATA)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:INHAL:BRTHG HIGH CONCS OF VAP CAN CAUSE LT-
HEAD, GIDD, SHORT OF BREATH & MAY LEAD TO NARCOS, CARD IRREGS,
UNCON/DEATH. SKIN:IRRIT/REDDENING MAY OCCUR DUE TO DEFATT.
INGEST:MAY CAUSE NAUSEA & VOMIT. A SPIR INTO LUNGS MAY RESULT IN
CHEM PNEUM & PULM EDEMA WHICH IS POTNTLY FATAL COND.EYE:CNTCT MAY
CAUSE EXTREME DISCOMFORT
Medical Cond Aggravated by Exposure:CARDIOVASCULAR DISEASE.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR & CALL MD. IF NOT BRTHG, GIVE ARTF
RESP, PREF MOUTH-TO-MOUTH. IF BRTHG DFCLT GIVE O2. DO NOT GIVE
EPINEPHRINE OR SIMILAR DRUGS. SKIN:FLUSH W/WATER. IF IRRIT OCCURS/
PERSISTS, GET MD. INGEST:DO NOT INDUCE VOMIT. IFVOMIT OCCURS KEEP
HEAD BELOW HIPS TO REDUCE RISK OF ASPIR MATL INTO LUNGS. GET MD
IMMED. EYE:IMMED FLUSH W/WATER FOR AT LEAST 15 MIN. GET MD. (SEE
ING 12)
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:NONE
Lower Limits:NONFLAMMABLE
Upper Limits:NONFLAMMABLE
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD PRESS DEMAND SCBA &
FULL PROT EQUIP . ADDTN OF EXCESS WATER (>0.2%) WILL EXTRACT
ALCOHOL & MAY FORM FLAMM SUPERNANT LIQUID LAYER.
Unusual Fire/Explosion Hazard:PRESSURIZED AEROSOL CNTNRS MAY VENT,
RUPTURE/EXPLODE & ADD TO FLYING & FALLING DEBRIS. DECOMP MAY OCCUR.
THERMAL DECOMP PRODS MAY INCLUDE HCL & PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE OPEN FLAMES OR OTHER
SOURCES OF IGNITION. COLLECT SPILLED PRODUCT W/ABSORBENT MATERIAL &
PLACE IN CLOSED STEEL DRUMS FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR SOURCES OF HEAT, IN
DIRECT SUNLIGHT OR WHERE TEMPERATURES EXCEED 120F. DO NOT PUNCTURE
OR DAMAGE CONTAINERS. ROTATE STOCK.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GEN VICIN OF
ARC WELDING, OPEN FLAMES/HOT SURFS. HEAT &/OR UV RADIA MAY CAUSE
FORMATION OF HCL &/OR PHOSGENE . PROD CONTAINS
1,1,1-TRICHLOROETHANE SUBJEC T TO REPORTING RQMNT OF (SEE ING 14)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NORM VENT FOR STD MFG PROCS GEN ADEQ. LOCAL EXHST SHOULD BE
USED WHEN LG AMTS RELEASED. MECH VENT IN LOW PLACES.
Other Protective Equipment:EYE BATH AND PROTECTIVE CLOTHES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
DECOMP PRODS:& HYDROFLUORIC ACIDS & POSS CARBONYL HALIDES. HCL,
PHOSGENE . HLTH HAZ:NOTE:IN SCREENING STUDIES W/EXPT ANIMALS, EXPOS
AT APPROX 5,000PPM (V/V) & ABOVE, FOLLOWED BY LG IV EPINEPHRIN E
CHALLENGE HAS INDUCED SERIOUS CARDIACIRREGS. CHLOROCARBON MATLS
HAVE PRODUCED (SEE ING 5)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:166F,74C
Vapor Pres:93 @68F
Vapor Density:4.5
Spec Gravity:1.25
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1).
Solubility in Water:5G/100CC
Appearance and Odor:CLEAR, COLORLESS LIQUID, ETHEREAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI/ALKALINE EARTH METALS-POWDERED AL, ZN, BE, OR MG. ALSO REACTS
W/STRONG CAUSTICS, ACETONE & NITRATES. CORR TO AL.
Stability Condition to Avoid:AVOID SPRAYING NEAR OPEN FLAMES OR RED HOT
SURFACES. DO NOT HEAT AEROSOL CONTAINERS ABOVE 120F/49C.
Hazardous Decomposition Products:COMPOUND CAN BE DECOMPOSED BY HIGH
TEMPS (OPEN FLAMES, GLOWING METAL SURFS, ETC.)FORMING HYDROCHLORIC
(SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY W/ALL FEDERAL, STATE, AND LOCAL
REGULATIONS. DO NOT PUNCTURE OR INCINERATE AEROSOL CANS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CAUSTIC POTASH 45% LIQUID
CAGE:81355
CAGE:5A188
CAGE:81355
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
= Wt:45.
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
= Wt:55.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:CORROSIVE,CAUSE SEVERE EYE DAMAGE &
EVEN BLINDNESS RAPIDLY; CAUSE SKIN BURNS & DEEP ULCERATION;
BREATHING OF MIST CAN CAUSE DAMAGE TO NASAL & RESPIRATORY PASSAGES;
SWALLOWING RESULTS IN SEVERE DAMAGE TO MUCOUS MEMBRANES & DEEP
TISSUES. CANRESULT IN DEATH ON PENETRATION TO VITAL AREAS.
Effects of Overexposure:CAUSE SEVERE BURNS & IRRITATIONS.
======================= First Aid Measures =======================
First Aid:EYE/SKIN:FLUSH WITH LARGE AMOUNTS OF WATER FOR 15
MINUTES,REMOVE CONTAMINATED CLOTHING,LAUNDER BEFORE REUSE,
OCCASIONALLY LIFTING EYELIDS WHEN FLUSHING EYES; ING:DO NOT INDUCE
VOMITING,DILUTE BY GIVIN G WATER,GIVE MILK OR MAGNESIA,KEEP
WARM,QUIET,GET MEDICAL ATTENTION; INH:REMOVE TO FRESH AIR,IF
BREATHING IS DIFFICULT, ADMINISTER OXYGEN; GIVE ARTIFICIAL
RESPIRATION IF BREATHING HAS STOPPED.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG
Fire Fighting Procedures:USE WATER TO KEEP FIRE-EXPOSED CONTAINERS
COOL;WEAR SELF-CONTAINED BREATHING APPARATUS WITH A FULL FACEPIECE
OPERATED IN PRESSURE DEMAND OR POSITIVE MODE.
Unusual Fire/Explosion Hazard:CAN REACT WITH CHEMICALLY REACTIVE METALS
SUCH AS ALUMINUM,ZINC,MAGNESIUM,ETC.
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE & MOP UP SOLUTION.
Neutralizing Agent:WEAK ACID SUCH AS ACIDIC ACID,OR 6M-HYDROCHLORIC
ACID.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH/MSHA APPROVED RESPIRATOR
Ventilation:PROVIDE SUFFICIENT MECHANICAL VENTILATION TO KEEP BELOW
TLV.
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:=132.8C, 271.F
Vapor Pres:2
Spec Gravity:1.45
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS,ORGANIC MATERIALS,REACTIVE
METALS:ALUMINUM,ZINC,MAGENSIUM;STRONG ORGANIC ACIDS,COPPER.
Stability Condition to Avoid:NONE STATED
Hazardous Decomposition Products:NONE STATED.
==================== Disposal Considerations ====================
Waste Disposal Methods:NEUTRALIZE WITH 6M-HYDROCHLORIC ACID & FLUSH
DOWN DRAIN WITH EXCESS WATER IN ACCORDANCE WITH APPLICABLE
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:27900 FLUOROURACIL 250 MG
Preparer's Name:JEROME A HALPERIN
CAGE:14128
CAGE:14128
============= Composition/Information on Ingredients =============
Ingred Name:FLUOROURACIL, 5-FLUOROURACIL
CAS:51-21-8
RTECS #:YR0350000
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 230 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE ADVERSE EFFECTS OF FLUOROURACIL
MAY BE SEVERE & SOMETIMES FATAL. IRRITATING TO EYES, SKIN &
RESPIRATORY TRACT. POSSIBLE HYPERSENSITIZATION. INGESTION:
IRRITATION. BONE MARROW SUPPRESSION ARE DELAY ED ADVERSE EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:LOSS OF APPETITE/STOMACH
CRAMPS/NAUSEA/VOMITING/HEARTBURN/DIFFICULTY INGESTING/INFLAMED
MOUTH/LIPS/DIARRHEA/FEVER/CHILLS/PAIN/BLEEDING/DIFFICULT
URINATION/BLACK & TARRY STOOLS/BRUISING/RED SPOTS/RASH/
ITCHING/SORENESS/BURNING/CHEST PAIN/SHORTNESS OF BREATH/LOSS OF
BALANCE/HAIR LOSS/JAUNDICE/IRRITATION.
Medical Cond Aggravated by Exposure:HYPERSENSITIVITY/IMPAIRED
LIVER/KIDNEY FUNCTION/BONE MARROW DEPRESSION/CHICKENPOX/HERPES
ZOSTER/EYTOTOXIC DRUG THERAPY W/ALKYLATING AGENTS/HIGH DOSE PELVIC
RADIATION THERAPY.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/COPIOUS
AMOUNTS OF TEPID WATER FOR 15 MINS. SKIN: FLUSH W/COPIOUS AMOUNTS
OF SOAP & WATER. INGESTION: FLUSH OUT MOUTH W/WATER. OBTAIN MEDICAL
ATTENTION I N ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2/FOAM AS APPROPRIATE
TO SURROUNDING FIRE & MATERIALS.
Fire Fighting Procedures:EVACUATE PERSONNEL TO SAFE AREA. USE SCBA &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:COMBUSTIBLE. EMITS TOXIC FUMES UNDER FIRE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROVED RESPIRATOR & CHEMICALLY
APPROPRIATE CONTAINER FOR WASTE DISPOSAL. VENTILATE AREA & WASH
AREA SITE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHT, LIGHT RESISTANT
CONTAINER. MATERIAL SHOULD BE HANDLED & STORED PER LABEL & OTHER
INSTRUCTIONS TO ENSURE PRODUCT.
Other Precautions:AVOID CONTACT W/EYES, SKIN/CLOTHING. AVOID BREATHING
DUST/MIST. USE W/ADEQUATE DUST CONTROL. DON'T PERMIT EATING,
DRINKING/SMOKING NEAR MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST/MECHANICAL (GENERAL): RECOMMENDED.
Other Protective Equipment:LABORATORY APPAREL.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MELTING POINT: 539.6-541.4F.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:(SEE SUPP)
Solubility in Water:SPARINGLY SOLUBLE
Appearance and Odor:WHITE TO NEARLY WHITE CRYSTALLINE POWDER;
PRACTICALLY ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES.
Stability Condition to Avoid:LIGHT & EXTREME HEAT.
Hazardous Decomposition Products:PHOSPHOROUS, NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NITRIC ACID, A200 612GAL
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:NITRIC ACID (SARA 302/313) (CERCLA)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 69-71%
OSHA PEL:2 PPM
ACGIH TLV:2 PPM/4 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER LD50 (ORAL RAT): 90 ML/KG
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 29-31%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 2.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: NONE. ACUTE: EYE: SEV
EYE BURNS. MAY CAUSE IRREVERSIBLE EYE INJURY. SKIN: MAY CAUSE SEV
IRRIT. CAUSES SKIN BURNS. MAY CAUSE DEEP, PENETRATING ULCERS OF
SKIN. INGEST: GI TRACT BURNS. MAY CAUSE PERFORATION OF DIGESTIVE
TRACT. INHAL: MAY BE FATAL IF INHALED. EFTS MAY BE DELAYED. MAY
CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: IRRIT OF RESP TRACT W/BURNING PAIN IN
NOSE & THROAT, COUGHING, WHEEZING, SHORTNESS OF BRTH & PULM EDEMA.
CHRONIC: RPTD INHAL MAY CAUSE CHRONIC BRONCHITIS. REPEATED EXPOSURE
MAY CAUSE EROSION OF TEETH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN, OCCAS
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW VICTIM
TO RUB/KEEP EYES CLSD. SKIN: FLUSH W/PLENTY OF SOAP & WATER FOR AT
LEAST 15 MIN WHILE REMOVING CONTAM CLTHG & SHOES. GET MED AID IF
IRRIT DEVELOPS/PERSISTS. WASH CLTHG BEFORE REUSE. INGEST: DO NOT
INDUCE VOMIT & SEEK IMMED MED ADVICE. INHAL: REMOVE TO FRESH AIR
(SUP DAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:SUBSTANCE IS NON-COMBUSTIBLE; USE AGENT MOST
APPROPRIATE TO EXTINGUISH SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS COOL.
SUBSTANCE IS NON-COMBUSTIBLE.
Unusual Fire/Explosion Hazard:STRONG OXIDIZER. CONTACT WITH COMBUSTIBLE
MATERIALS MAY CAUSE A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL WITH INERT MATERIAL (E.G., DRY
SAND OR EARTH), THEN PLACE INTO A CHEMICAL WASTE CONTAINER. WEAR
NIOSH APPROVED SCBA & APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT
(SEE CONTROL MEASURES SECTI ON).
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. DO NOT
GET IN EYES OR ON SKIN. DO NOT INGEST OR INHALE.
Other Precautions:STORE IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM
INCOMPATIBLE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29CFR 1910.134. ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN
EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
MATLS TO AVOID: MATERIALS AND COMBUSTIBLES. FIRST AID PROC: IMMED. IF
NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. GET MED
AID. NOTES TO MD: TREAT SYMPTOMATICALLY & SUPPORTIVELY. NO SPEC
IFIC ANTIDOTE EXISTS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:187F,86C
Melt/Freeze Pt:M.P/F.P Text:-44F,-42C
Vapor Pres:6.8
Spec Gravity:1.50
pH:1.0
Solubility in Water:SOLUBLE
Appearance and Odor:TRANSPARENT, CLEAR OR YELLOWISH LIQUID. STRONG,
ACRID ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS W/OVER 150 CHEMICAL COMBINATIONS. REFER TO NFPA FIRE PROT GUIDE
FOR SPECIFICS. REACTS VIOLENTLY W/ORG (SUP DAT)
Stability Condition to Avoid:HIGH TEMPS, INCOMPATIBLE MATERIALS,
MOISTURE, REDUCING AGENTS. DECOMPOSES WHEN IN CONTACT W/AIR,
LIGHT/ORGANIC MATTER.
Hazardous Decomposition Products:NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: P3 OIL
Cage: 1B0F1
=======================================================
Contractor Summary
=======================================================
Cage: 1B0F1
=======================================================
Ingredients
=======================================================
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
WATER, SEWER SYS/SUBSOIL, NOTIFY COMPETENT AUTH.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50: (ORAL,RAT) >2000 MG/KG
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: AVOID FORMATION OF OIL MISTS! EXTENDED OR REPEATED SKIN
CONTACT MAY RESULT IN DERMATITIS. IF USED AS PRESCRIBED, NO SPECIAL HEALTH
HAZARDS. IRRITATING/CAUSTIC EFFECT: SLIGHT IRRITATION OF SKIN POSSIBL E IN
EVENT OF REPEATED EXPOSURE. NO SENSITIZATION EFT EXPECTED. EFFECTS AFTER
REPEATED OR EXTENDED (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: EXPOSURE (SUBACUTE OR CHRONIC
TOXICITY): REPEATED OR EXTENDED CONTACT W/SKIN MAY RESULT IN SKIN DEGREASING
& DERMATITIS. THE SKIN MAY THEREFORE BE MORE SENSITIVE TO OTHER IRRITANT
SUBSTANCES . CARCEROGENIC, GENOTYPE-MUTATING & REPROD-INHIBITING EFT:
PROD IS BASED ON MINERAL OIL RAFFINATE WHICH HAS NOT (SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: BRING PATIENT TO FRESH AIR & LAY DOWN IN QUIET LOCATION.
GET MED ADVICE. SKIN: REMOVE SOILED CLOTHES & WASH AFFECTED SKIN PARTS
W/WATER & SOAP. IF PROD PENETRATES SKIN UNDER HIGH PRESS, IMMED C ALL FOR
MED ASSISTANCE! EYES: THORO RINSE IMMED FOR @ LST 15 MINS, USING FLOWING
WATER & SPREADING EYELIDS. CONSULT MD. INGEST: DO NOT INDUCE VOMIT. GET
MED ADVICE. INFO FOR MD: SYMPTOMATIC TREATMENT.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ABSORB/CNTN USING SAND, SOIL/ABSORB MATL. SHOVEL INTO
LBLD CNTNR & THEN DISPOSE I/A/W OFFICIAL REGS. THORO AFFECTED ROOMS.
AVOID CONT W/SKIN. ENVIRONMENTAL HAZS: DO NOT LET PROD ESCAPE TO ENVIRONMENT
UNCONTROLLED, BECAUSE IT IS NOT FULLY (SUPDAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). HAND OVER TO AN AUTHORIZED DISPOSAL COMPANY. COMPLETELY
EMPTY CNTNRS. TO BE CLEANED BY RECYCLING COMPANY.
Handling And Storage Precautions: AVOID SOLAR RADIA, DIRECT HEAT SOURCES &
STRONG OXIDANTS. DO NOT STORE TOGETHER W/STRONG OXIDANTS.
Other Precautions: SUITABLE STOR MATL: STEEL & HD POLYETHYLENE FOR STOR
CNTNRS. IF HEAVY CNTNRS MUST BE HNDLD, SAFETY BOOTS & SUITABLE TOOLS MUST
BE USED. AVOID ANY SPILLING OF PRODUCT.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 507F,264C
Extinguishing Media: FOAM, POWDER, CARBON DIOXIDE, SAND OR SOIL. DO NOT USE A
SHARP WATER JET.
Fire Fighting Procedures: NONE. USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: IF THERE IS UNCONTROLLED FIRE, COMPLEX
GAS-AEROSOL MIX ARE PRDCED WHICH MAY CONTAIN CARBON MONOXIDE, NITROGEN
OXIDES, SOOT, SULPHUR DIOXIDE & ORGANIC COMPOUNDS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT REQUIRED UNDER NORMAL CONDITIONS. IF OIL MISTS ARE
PRODUCED, WEAR NIOSH APPROVED FACE MASK WITH FILTER FOR ORGANIC VAPORS &
PARTICLE FILTER.
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N). USE
SKIN CREAM. AVOID CONT W/SKIN. WEAR OVERALLS AS PROTECTIVE CLOTHING.
Work Hygienic Practices: DO NOT EAT, DRINK, SMOKE, SNUFF DURING WORK. DO NOT
CARRY CLEANING RAGS SATURATED W/PROD IN YOUR CLOTHES.
Supplemental Safety and Health: VP: <0.01 HPM @ 20C. EFTS OF OVEREX: SHOWN
ANY CARCIN POTNTL IN ANIMAL TESTS. NO INFO IS AVAIL ON CARCIN EFTS OF OTHER
CONSTITUENTS. SPILL PROC: BIODEGRADABLE. ENVIRONMENTAL PROT: PVNT ANY FURTHER
LEA KAGE & DISCHARGE INTO SEWER SYS. PVNT DISCHARGE INTO DRAINAGE SYS BY
SETTING BARRIERS OF SAND/SOIL/BY OTHER
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 5F,-15C
Vapor Pres: SUPDAT
Evaporation Rate & Reference: NOT KNOWN
Solubility in Water: NOT KNOWN
Appearance and Odor: TRANSPARENT LIQUID.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: STABLE IF USED AS PRECRIBED.
Materials To Avoid: STRONG OXIDANTS.
Hazardous Decomposition Products: NO HAZARDOUS DECOMPOSITION PRODUCTS UNDER
NORMAL STORAGE CONDITIONS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: P3 OIL
Cage: 1B0F1
Company Name: PFEIFFER VACUUM TECHNOLOGY INC
Street: 24 TRAFALGAR SQ
Zipcode: 03063
Label Required IND: Y
Date Of Label Review: 06/09/1998
Status Code: C
Label Date: 06/09/1998
Origination
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: AVOID FORMATION OF OIL MISTS! EXTENDED OR
REPEATED SKIN CONTACT MAY RESULT IN DERMATITIS. IF USED AS PRESCRIBED, NO
SPECIAL HEALTH HAZARDS. IRRITATING/CAUSTIC EFFECT: SLIGHT IRRITATION OF SKIN
POSSIBLE IN EVENT OF REPEATED EXPOSURE.NO SENSITIZATION EFT EXPECTED. EFFECTS
AFTER REPEATED OR EXTENDED EXPOSURE (SUBACUTE OR CHRONIC TOXICITY): REPREATED
OR EXTENDED CONTACT WITH SKIN MAY RESULT IN SKIN DEGREASING &
DERMATITIS. THE SKIN MAY THEREFORE BE MORE SENSITIVE TO OTHER IRRITANT
SUBSTANCES.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MINERAL FIBER CEILINGS & WALL PANELS
CAGE:03938
CAGE:03938
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL WOOL FIBER
Fraction by Wt: 20-60%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (HYDROUS ALUMINUM SILICATE)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 4-10%
OSHA PEL:0.1 MG/M3 (MFR)
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:HYGIENE PRACT:WORK CLOTHES SEPARATELY, & THEN RINSE WASHER.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:MATLS ARE TRANSIENT MECH IRRIT
TO SKIN, EYES & UPPER RESP SYS. REFER TO SPECIAL PROT INFO FOR
HNDLG INSTRUCTIONS. CHRONIC:RECENT U.S., CANADIAN & EUROPEAN
STUDIES OF ALMOST 72,000 PRODUCTION WOR KERS (1930'S TO 1980'S)
FOUND SLIGHT INCR IN INCIDENCE OF LUNG CANCER AMONG THOSE WORKERS
EMPLOYED IN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, SUPP, VOL 7, PG 341, 1987:GRP 2B. NTP 7TH ANNUAL RPT ON
CARCINS, (SUPP DATA)
Effects of Overexposure:HLTH HAZ:INDUSTRY 30 YRS AGO. MUCH OF THIS
APPARENT INCR CAN BE EXPLAINED BY DIFFS IN CNDTNS & MATLS USED IN
MINERAL WOOL PRODUCTION PLANTS THEN VERSUS NOW. WORKERS FROM MORE
RECENT PERIODS HAVE SHOWN NO SIGNIFICANT INCR IN DISEASE FROM
MINERAL WOOL EXPOS. BASED ON LTD EVID FROM HUMAN STUDIES, IARC HAS
REC A 2B(SUPDAT)
Medical Cond Aggravated by Exposure:ANY CONDITION GENERALLY AGGRAVATED
BY RESPIRATORY & MECHANICAL IRRITANTS IN AIR OR ON SKIN.
PRE-EXISTING UPPER RESPIRATORY & LUNG DISEASES SUCH AS, BUT NOT
LIMITED TO BRONCHITIS, EMPHYSEMA & ASTHMA.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . SKIN:WASH W/MILD SOAP &
RUNNING WATER. EYES:FLUSH W/FLOWING WATER FOR AT LEAST 15 MINUTES &
IF SYMPTOMS PERSIST, SEEK IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG, DRY CHEMICAL, ABC RATED.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:INSTALL IN WELL VENTILATED AREAS &
AVOID BREATHING DUST. HANDLE THESE MATERIALS CAREFULLY TO MINIMIZE
AIRBORNE DUST.
Other Precautions:ALL POWER TOOLS MUST BE EQUIPPED W/DUST COLLECTORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF HIGH DUST LEVELS ARE ANTICIPATED DURING
INSTALLATION, SUCH AS W/USE OF POWER TOOLS, USE APPROPRIATE NIOSH
APPROVED DUST RESPIRATOR.
Ventilation:INSTALL IN WELL VENTILATED AREAS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR LOOSE, COMFORTABLE CLTHG & LONG-
(SUPDAT)
Work Hygienic Practices:AFTER USING THESE MATLS, WASH W/WARM WATER &
MILD SOAP. DO NOT SCRATCH/RUB SKIN IF IT BECOMES IRRITATED. WASH
(ING 3)
Supplemental Safety and Health
EXPLAN OF CARCIN:1994:ANTIC TO BE CARCIN. EFTS OF
OVEREXP:CLASSIFICATION OF MINERAL WOOL AS POSS CARCIN TO HUMANS.
LONG TERM EXPOS TO FREE SILICA DUST IN CONCS HIGHER THAN REC
PEL/TLV MAY CAUSE SILICO SIS. TARGET ORGANS:LUNGS, SKIN & EYES.
OTHER PROT EQUIP:SLEEVED SHIRTS TO MIN SKIN CONT W/THESE MATERIALS.
================== Physical/Chemical Properties ==================
Appearance and Odor:GRAY, PRESSED FIBROUS PANEL OF VARIOUS COLORS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE & OTHER TRACE PYROLYSIS
PRODUCTS TYPICAL OF DECOMPOSITION OF ANY ORGANIC CHEMICAL.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS. THE PRIMARY METHOD OF DISPOSAL IS IN A MUNICIPAL OR
INDUSTRIAL LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KEMACRYL ENAMEL LEAD COLORS IMPLEMENT RED,
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:VENT: REFER TO OSHA STANDARDS 1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
Ingred Name:LEAD SULFOCHROME; (LEAD CHROMATE) CONTAINING <12.5 % ING 9
& <2.2 % ING 10. TLV:0.05 MG/M3 (PB), 0.012 (CR)
CAS:1344-37-2
Fraction by Wt: <20%
OSHA PEL:0.05 MG/M3 (MFR)
ACGIH TLV:SEE ING NAME
Ingred Name:MOLYBDATE ORANGE CONTAINING <12.5% ING 9 & <2.2 % ING 10
CAS:12656-85-8
RTECS #:QA4660000
Fraction by Wt: <20%
ACGIH TLV:0.05 MG/M3 (MFR)
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: < 12.5%
OSHA PEL:0.05 MG/M3
ACGIH TLV:0.15 MG/M3;DUST
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CHROMIUM (SARA III) (CHROMIUM VI (AS CR))
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: <2.2%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SUPP DATA:SUCH EXPOS LEVELS ARE NOT ATTAINABLE IN THE
WORKPLACE. REPORTS HAVE ASSOC RPTD & PRLNGD OVEREXP TO (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:SOLVS W/PERMANENT BRAIN & NERV SYS DMG. INTENTIONAL
MISUSE BY DELIBERATELY CONC & INHAL THE CONTENTS CAN (ING 13)
RTECS #:9999999ZZ
Other REC Limits:N/KJ
Ingred Name:ING 12:BE HARMFUL/FATAL. LEAD (7439-92-1) & TOLUENE
(108-88-3) APPEAR ON THE NAVY LISTING OF OCCUP REPROD HAZ. (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS
CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: RECOMMENDATIONS .
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: CNTNRS W/COMPLETE & APPROP LABELING. DO NOT
TAKE INTERNALLY. KEEP OUT OF THE REACH OF CHILDREN. (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:THIS COATING CNTNS MATLS CLASSIFIED AS NUISANCE
PARTICULATES, FOR EXAMPLE TITANIUM DIOXIDE, CALCIUM (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:CARBONATE, ETC. WHICH MAY BE PRESENT AT HAZ LEVELS
ONLY DURING SANDING OR ABRADING OF THE DRIED FILM. (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: CONTAINS LEAD. DO NOT APPLY ON TOYS & OTHER
CHILDREN'S ARTICLES, FURNITURE, OR ANY INTERIOR SURF OF A (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: DWELLING/FACILITY WHICH MAY BE OCCUPIED/USED BY
CHILDREN. DO NOT APPLY ON EXTERIOR DWELLING UNITS, SUCH (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: AS WINDOW SILLS, PORCHES, STAIRS, OR RAILING TO
WHICH CHILDREN MAY BE COMMONLY EXPOSED.
RTECS #:9999999ZZ
Ingred Name:VM & P MAPHTHA. VP: 12.0
CAS:64742-48-9
Fraction by Wt: 30-50%
OSHA PEL:300 PPM, 400 STEL
ACGIH TLV:300 PPM
Ingred Name:TOLUENE (SARA III). VP: 22
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 0-5%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOBUTYL ALCOHOL; (2-METHYL-1-PROPANOL) (SARA III). VP: 8.7
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 0-5%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-PENTANONE, 4-METHYL-; (METHYL ISOBUTYL KETONE) (SARA
III). VP: 16
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 0-5%
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID, ISOBUTYL ESTER; (ISOBUTYL ACETATE) (SARA
III). VP: 12.5
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 5-10%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE).
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-30%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: OVEREXP CAUSES EYE, SKIN & RESP
IRRIT. MAY CAUSE NERV SYS DEPRESS ACCOMPANIED BY HDCH, DIZZ, NAUS,
CONFUSION & STAG GAIT. EXTREME OVEREXP MAY RESULT IN UNCON & POSS
DEATH. CHRONIC: ALTHOUGH STU DIES HAVE ASSOC EXPOS TO CHROMIUM VI
CMPNDS W/AN INCR RISK OF RESP CANCER, AVAIL EVIDENCE INDICATES (EFS
OF OVEREXP)
Explanation of Carcinogenicity:MOLYBDENUM ORANGE: GROUP 1 (IARC).
Effects of Overexposure:HLTH HAZ:THAT LEAD CHROMATE (CHROME YELLOW,
MOLYBDATE ORANGE) DOES NOT PRESENT THIS HAZ. PRLNGD OVEREXP TO
INGRED IN INGRED SEC MAY CAUSE ADVERSE EFTS TO THE LIVER, URINARY,
BLOOD FORMING, CARDIO-VASC ULAR, GI, NERV, & REPROD SYS (INCL
EMBRYOTOXIC EFTS.) RATS EXPOSED TO TITANIUM DIOXIDE DUST AT 250
MG/M3 (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP
AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE.
EYES: FLUSH EYES WITH LARGE AMOUNTS OF WATERFOR AT LEAST 15 MIN.
GET MEDICAL ATTENTION. INGEST: GET MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>22F,>-6C
Lower Limits:0.9%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. H*2O SPRAY MAY BE INEFTIVE. IF H*2O IS USED, FOG NOZZ ARE
PREFERABLE. H*2O MAY BE USED TO COOL(SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT/ELEC EQUIP/SPARKS/OPEN FLAME. CLSD CNTNRS MAY EXPLO WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT SURF(SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE FLAMM. KEEP AWAY FROM
HEAT/SPARKS & OPEN FLAME. DURING USE & UNTIL ALL VAPS ARE GONE:
KEEP AREA VENT. DO NOT SMOKE.
Other Precautions:EXTING ALL FLAMES, PILOT LIGHTS, & HEATERS. TURN OFF
STOVES, ELEC TOOLS & APPLIANCES, & ANY OTHER SOURCES OF IGNIT.
CONSULT NFPA CODE. USE APPRVD BONDING & GROUNDING PROC. KEEP CNTNR
CLSD WHEN NOT IN USE. TRANSFER ONLY TO APPRVD (ING 16)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENT, WEAR RESP DEVICE APPROVED BY NIOSH/MSHA
FOR PROT AGAINST MATLS IN INGRED SECTION.
Ventilation:LOC EXHST PREFERABLE. GEN EXHST ACCEPT IF THE EXPOS TO
MATLS IN ING SEC IS MAINTAINED BELOW APPLIC EXPOS LIMITS.(ING 22)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:CLSD CNTNRS TO PVNT PRESS BUILD-UP & POSS
AUTOIGNIT/EXPLO WHEN EXPOSED TO EXTREME HEAT. EXPLO HAZ:REQUIRES
SPECIAL PREC. DURING EMERGENCY CNDTNS OVEREXP TO DECOMP PRODS MAY
CAUSE A HEA LTH HAZ. SYMPTOMS MAY NOT BE IMMED APPARENT. OBTAIN MED
ATTN. EFTS OF OVEREXP: DEVELOPED LUNG CANCER, HOWEVER, (ING 11)
================== Physical/Chemical Properties ==================
HCC:F5
Boiling Pt:B.P. Text:>222F,>106C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.863-1.14
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:64-70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENT SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER RCRA
40CFR261.WASTE MUST BE TESTED FOR IGNIT & EXTRACTABILITY TO
DETERMINE THE APPLIC EPA HAZ WASTE NO.INCIN IN APPRVD FACIL.DO NOT
INCIN CLSD CNTNR. DISP O F I/A/W FED, STATE & LOC REGS
REGARDINGPOLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PHILLYBOND SUPER ALLOY RESIN,PART B
CAGE:20420
CAGE:20420
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN,DIGLYCIDYL ETHER OF BISPHENOL
A.IRRITANT,SENSITIZER.
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TALC.(MAGNESIUM SILICATE HYDRATE).ACGIH TWA IS FOR RESP
DUST.
CAS:14807-96-6
RTECS #:VV7720000
Other REC Limits:N/K
OSHA PEL:20 MPPCF TWA DUST
ACGIH TLV:2 MG/CUM TWA (1989)
Ingred Name:SILICA, AMORPHOUS, DUST
CAS:112945-52-5
RTECS #:VV7310000
Other REC Limits:N/K
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3; 8990
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:MINOR TRANSIENT IRRITATION.NO CORNEAL
INJURY.SKIN:PROLONGED OR REPEATED CONTACT MAY CAUSE IRRITATION OR
SENSITIZATION.INGESTION:N/K.INHALATION:NOT LIKELY A PROBLEM UNLESS
CURED MATERIAL IS MACHIN ED,AT WHICH TIME IRRITATION OF RESPIRATORY
TRACT MAY OCCUR IF PROPER RESPIRATORY PROTECTION IS NOT USED.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR 15 MIN.AND SEEK A PHYSICIAN'S
ATTENTION.SKIN:WASH WITH SOAP AND WATER.IF IRRITATION PERSISTS,SEEK
A PHYSICIAN'S ATTENTION.INGESTION:N/K.INHALATION:REMOVE TO FRESH
AIR.SUPPORT BREATHING (GIVE O*2/ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>400F,204C
Extinguishing Media:CARBON DIOXIDE OR DRY CHEMICALS.POLYMER FOAM FOR
LARGE FIRES.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .AVOID BREATHING SMOKE.
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE CARBON MONOXIDE,CARBON DIOXIDE,ALDEHYDES AND ACIDS FROM
INCOMPLETE COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID SKIN CONTACT.SCRAPE UP AND DISPOSE OF
CONTAMINATED MATERIAL IN SUITABLE CONTAINERS.CLEAN RESIDUE WITH
SAFETY SOLVENT.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:PRACTICE GOOD HOUSEKEEPING PROCEDURES
TO AVOID ALL SKIN CONTACT AND TO AVOID BREATHING VAPORS.
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:CLEAN LONG LEG AND SLEEVED CLOTHING.
Work Hygienic Practices:PRACTICE GOOD HOUSEKEEPING PROCEDURES.
Supplemental Safety and Health
N/K
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:N/K
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:NIL @ 78F
Vapor Density:N/K
Spec Gravity:1.70 (H*2O=1)
Evaporation Rate & Reference:NON-VOLATILE
Solubility in Water:INSOLUBLE
Appearance and Odor:VISCOUS GRAY PASTE WITH A LOW ODOR.
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZING AGENTS.
Stability Condition to Avoid:OPEN FLAME AND EXCESSIVE HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON
DIOXIDE,ALDEHYDES AND ACIDS FROM INCOMPLETE COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SUPER CLEAN WINDSHIELD PRE MIX
CAGE:9V419
CAGE:9V419
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 64%
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 36%
Other REC Limits:200 PPM
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXTREMELY PROLONGED EXPOSURES MAY LEAD
TO ABNORMAL KIDNEY & LIVER FUNCTIONS OR POSSIBLE FATALITY FOR GROSS
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: WEAKNESS, DIZZINESS, NAUSEA.
INGESTION: VOMITING, COMA. CENTRAL NERVOUS SYSTEM INVOLVMENT. EYE:
DAMAGE TO OPTIC NERVE.
Medical Cond Aggravated by Exposure:PRE-EXISTING LIVER DISEASES &
DISEASES OF THE RETINA.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. KEEP PATIENT QUIET, GIVE CPR
IF NEEDED. SKIN/EYES: WASH W/PLENTY OF WATER FOR AT LEAST 15 MINS.
INGESTION: INDUCE VOMITING IF CONSCIOUS. OBTAIN MEDICAL ATTENTION
IN AL L CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:120F
Lower Limits:0.6%
Upper Limits:36.5%
Extinguishing Media:WATER, CO2, DRY CHEMICAL
Unusual Fire/Explosion Hazard:TOXIC VAPORS EXPLOSIVE MIXTURES IN AIR,
CONTROL BY ADEQUATE VENTILATION & EXCLUSION OF SPARKS OR FIRES.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER. USE MASKS SUPPLIED W/AIR FROM
UNCONTAMINATED SOURCE TO ENTER AREA OF HIGH VAPOR CONCENTRATION.
KEEP ALL FLAMES & SPARKS AWAY.
======================Handling and Storage ======================
Handling and Storage Precautions:ALL EQUIPMENT SHOULD BE ELECTRICALLY
BONDED & GROUNDED. USE ONLY NON-SPARKING TOOLS. KEEP ALL CONTAINERS
TIGHTLY CLOSED.KEEP FROM HEAT/SPARKS/FLAME.
Other Precautions:DON'T STORE OR MIX W/STRONG OXIDIZERS OR SIMILAR
PRODUCTS. AVOID CONTACT W/SKIN/EYES & CLOTHES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS APPROPRIATE FOR LEVEL ENCOUNTERED.
Ventilation:LOCAL EXHAUST. MECHANICAL (GENERAL)
Other Protective Equipment:EYE WASH FOUNTAINS, PROTECTIVE COVERING
Work Hygienic Practices:FOLLOW ALL SAFETY PROCEDURES OUTLINED. ALWAYS
WASH HANDS THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:180F
Melt/Freeze Pt:M.P/F.P Text:100
Vapor Pres:92
Vapor Density:1.11
Spec Gravity:0.952
Evaporation Rate & Reference:(BU AC = 1 ): 4.6
Appearance and Odor:BLUE COLOR MOBILE LIQUID; CHARACTERISTIC ALCOHOL
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EXTREMELY STRONG OXIDIZERS
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAMES
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T ALLOW TO ENTER SEWERS WHERE VAPORS MAY
BECOME IGNITED. REMOVE WASTE TO A SAFE LOCATION, POUR ON DRY SAND
OR SIMILAR MATERIAL & CAUTIOUSLY IGNITE. DISPOSE OF IN ACCORDANCE
W/FEDERAL, STATE & LOCA L REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:806 4883 K-LAB YELLOW DEVELOPER REPLENISHER, PART A, K-14M
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 90-95%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SULFATE
CAS:7757-82-6
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM HYDROXIDE (CERCLA)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred
Name:4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-METHYLPHENYLENEDIA
MINE DI-P-TOLUENESULFONATE
CAS:50928-80-8
RTECS #:PB0431000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. EYE CONTACT CAUSES IRRITATION. SKIN
CONTACT CAUSES IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION.
EXPECTED TO BE A LOW INGESTION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, ALLERGIC SKIN
REACTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMEEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSTION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:MAY REQUIRE NEUTRALIZATION. FLUSH TO SEWER IF
ALLOWABLE WITH LARGE AMOUNTS OF WATER. OTHERWISE, ABSORB SPILL WITH
VERMICULITE OR OTHER INERT MATERIAL, THEN PLACE IN A CONTAINER FOR
CHEMICAL WASTE. CLE AN SURFACE TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER
HANDLING.
Other Precautions:THE ROUTINE USE OF A NONALKALINE (ACID) TYPE OF HAND
CLEANER AND REGULAR CLEANING OF WORKING SURFACES WILL HELP MINIMIZE
THE POSSIBILITY OF A SKIN REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:C2
NRC/State Lic Num:NOT GIVEN
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.05
pH:12.6
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, NO ODOR
Percent Volatiles by Volume:90-95%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COMBAT ROACH CONTROL SYSTEM
Preparer's Name:W. COSCARELLI
CAGE:70361
CAGE:70361
CAGE:0TNN7
CAGE:7A670
============= Composition/Information on Ingredients =============
Ingred Name:HYDRAMETHYLNON
CAS:67585-29-4
RTECS #:UW7583000
Fraction by Wt: 2%
Other REC Limits:1.4 MG/CUM
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL RAT = 1131 MG/KG ACTIVE INGRED
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS SLIGHTLY TOXIC BY DERMAL OR
ORAL.
Effects of Overexposure:MAY PRODUCE SLIGHT IRRITATION UPON OCULAR
CONTACT.
Medical Cond Aggravated by Exposure:NONE NOTED
======================= First Aid Measures =======================
First Aid:USE STANDARD FIRST AIR PROCEDURES. CALL EMERGENCY MEDICAL
CARE.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F(>93C)
Extinguishing Media:CO*2, FOAM, DRY CHEM & H*2O FOG.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:PLACE IN A CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR FOOD OR FEED
PRODUCTS. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NORMAL
Other Protective Equipment:NONE
Work Hygienic Practices:WASH AFTER HANDLING.
Supplemental Safety and Health
EPA REGISTRATION NO FOR THIS PRODUCT IS 1730-66.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F/100C
Melt/Freeze Pt:M.P/F.P Text:140F(60C)
Spec Gravity:1.44 G/ML
Solubility in Water:INSOLUBLE
Appearance and Odor:ODORLESS,PALE YELLOW TO YELLOWISH-BROWN,WAXY MASS
WITH SUSPENDED PARTICULATE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO,CO*2,METHANE,HYDROGEN FLUORIDE, &
OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:HARDENER 946
Kit Part:Y
CAGE:KO694
POLYMERS
CAGE:99384
CAGE:KO694
============= Composition/Information on Ingredients =============
Ingred Name:POLYALIPHATIC AMINE; ALIPHATIC COMPOUNDS
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:REPEATED/PROLONGED USE MAY CAUSE EYE,SKIN,UPPER
RESPIRATORY TRACT IRRITATION,SKIN SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF.NEED;EYES:FLUSH W
LG AMTS H*2O FOR 15 MIN;INGEST:RINSE MOUTH,AVOID EMETICS;GET
MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER SYMPTOMS
OF OVEREX POSURE;SKIN:DENAT ALCOHOL,THEN H*2O WASH
===================== Fire Fighting Measures =====================
Flash Point:265F,129.4C(COC)
Extinguishing Media:WATER, FOAM, OR DRY CHEMICAL POWER
Fire Fighting Procedures:USE WATER SPRAY TO COOL CONT, KNOCK-DOWN
VAPORS. WEAR SCBA.
Unusual Fire/Explosion Hazard:LOW BOILING AMINE FRAGMENTS FORMED BY
FIRE OR ABNORMAL TEMPERATURES;CONTAINERS MAY RUPTURE IN HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS. ELIM IGNITION
SOURCES. STOP LEAK. H*2O SPRAY COOL CONT/DIVERT SPILL FROM
FIRE/HEAT. PROVIDE VENTILATION. ABSORB W/COMMERCIAL
ABSORBENT,SHOVEL INTO METAL DRUMS:LG SPILL:DI KE W COMMERCIAL
ABSORBENT,PUMP INTO COVERED DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENT,LOW FIRE
RISK AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT.
KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:MAINTAIN STRICT HYGIENE, AVOID PHYSICAL CONTACT,
REMOVE & WASH CONTAMINATED CLOTHING. MFG SUGGESTS USE OF PROTECTIVE
SKIN CREAMS. EXHAUST CURING OVENS TO OPEN AIR. AVOID TEMPERATURE
EXTREMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA IN FIRE,OTHERWISE CHEM CARTR RESPIR.
Ventilation:MECHANICAL (GENERAL/LOCAL EXHAUST)
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
PART B OF 2 PART PRODUCT.THIS PART IS CATALYST.SEE P/N A FOR PART A
(BASE 4HI).PRODUCT MAY CAUSE ALLERGIC RESPONSES.KEY1:N1.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.06
Solubility in Water:SLIGHT
Appearance and Odor:BROWN LIQUID; STRONG AMMONIA ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
PEROXIDES,ACIDS
Stability Condition to Avoid:AVOID ELEVATED TEMPERATURE REACTION WITH
EPOXIES.
Hazardous Decomposition Products:NONE NOTED, BUT EXPECT CO, CO*2, H*2O
Conditions to Avoid Polymerization:ELEVATED TEMPERATURE REACTION WITH
EPOXIES.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED CONTAINERS PENDING DISPOSAL.
HANDLE AND DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE AND LOCAL REGULATIONS. MFG SUGGESTS
DISPOSAL AS SOLID WASTE(IN APPROV ED LANDFILL),OR INCINERATE;WASH
RESIDUEW DET/H*2O
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:524 PLASTIC PRIMER
CAGE:ACMEA
CAGE:ACMEA
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 85%
Other REC Limits:375 MG/CUM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 9%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WEIGHT PER GALLON IN POUNDS: 7.25
RTECS #:9999999WG
Ingred Name:VOL ORGANIC CMPD OR LESS WATER & EXEMPT SOLVENTS: 6.86
LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE, SKIN, OR RESPIRATORY IRRITANT.
NERVOUS SYSTEM DEPRESSION. EXTREME OVEREXPOSURE MAY CAUSE DEATH, OR
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. PROLONGED OVEREXPOSURE MAY
CAUSE ADVERSE EFFECTS TO THE LIVER, URINARY, BLOOD-FORMING,
CARDIO-VASCULAR SYSTEMS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, DIZZINESS, NAUSEA, LOSS
OF COORDINATION, UNCONSCIOUSNESS, DEATH. EYES/SKIN: REDNESS,
ITCHING OR BURNING SENSATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER
FOR 15 MINS. INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:40F
Lower Limits:0.7%
Upper Limits:12.7%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIP & SCBA. WATER SPRAY
MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
USE WATER TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT SURFACES REQUIRES
SPECIAL PRECAUTIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM IGNITION SOURCES.
DURING USE & UNTIL ALL VAPORS ARE GONE: KEEP AREA VENTILATED. DON'T
SMOKE. CONSULT NFPA CODE. DON'T TAKE INTERNALLY.
Other Precautions:EXTINGUISH ALL FLAMES, PILOT LIGHTS, & HEATERS. TURN
OFF STOVES, ELECTRIC TOOLS & APPLIANCES. USE APPROVED BONDING &
GROUNDING PROCEDURES. KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPRO VED CONTAINERS W/COMPLETE LABELING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
TLV, USE A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE RESPIRATOR
APPROVED BY NIOSH/MSHA. WHEN
SANDING/WIREBRUSHING/ABRADING/BURNING/WELDING DRIED FILM, U SE A
NIOSH/MSHA PARTICULATE RESPIRATOR.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL EXHAUST: ACCEPTABLE IF
THE EXPOSURE TO HAZARDOUS INGREDIENTS IS KEPT BELOW TLV.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING.
Supplemental Safety and Health
KEEP OUT OF REACH OF CHILDREN. AVOID BREATHING VAPOR/SPRAY MIST &
CONTACT W/SKIN/EYES. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.
PRODUCT IS PHOT OCHEMICALLY REACTIVE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:132-392F
Vapor Density:>1
Spec Gravity:0.87-0.95
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:85-100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME OR OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:BY FIRE: CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MAY BE HAZARDOUS UNDER THE RCRA. TEST
WASTE FOR IGNITABILITY TO DETERMINE THE APPLICABLE EPA HAZARDOUS
WASTE NUMBERS. INCINERATE IN APPROVED FACILITY. DON'T INCINERATE
CLOSED CONTAINER. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A-30
CAGE:67532
CAGE:0VWY3
CAGE:67532
============= Composition/Information on Ingredients =============
Ingred Name:SILVER
CAS:7440-22-4
RTECS #:VW3500000
OSHA PEL:0.01 MG/CUM
ACGIH TLV:0.1 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PLATINUM
CAS:7440-06-4
RTECS #:TP2160000
OSHA PEL:0.002 MG/M3
ACGIH TLV:0.002 MG/M3; 9394
Ingred Name:COPPER (DUST & MIST), BRONZE POWDER
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: <1%
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:INDIUM
CAS:7440-74-6
RTECS #:NL1050000
Fraction by Wt: <1%
OSHA PEL:0.1 MG/CUM
ACGIH TLV:0.1 MG/CUM
Ingred Name:TIN (AS SN)
CAS:7440-31-5
RTECS #:XP7320000
OSHA PEL:2.0 MG/CUM
ACGIH TLV:2.0 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: DISCOLORATION OR BLUE-GRAY
DARKENING, IRRITATION. METAL SOLUTIONS MAY CAUSE SWELLING &
ITCHING. BURNS. EYES: DISCOLORATION OR BLUE-GRAY DARKENING.
IRRITATION. INHALATION: METAL FUME FEVER. MODER ATELY TOXIC.
INGESTION: STOMACH PAIN, NAUSEA, VOMITING, DIARRHEA. EXTREMELY
TOXIC.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: FRAGMENTS IN THE CORNEA MAY CAUSE
CATARACTS, DISCOLORATION (KAPER-FLEISCHER RINGS) & LOSS OF THE
EYES. INHALATION: PERMNENT DAMAGE TO THE NERVOUS SYSTEM & DEATH.
Medical Cond Aggravated by Exposure:WILSON'S DISEASE
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/WATER. INGESTION: DON'T INDUCE VOMITING.
INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Extinguishing Media:DRY CHEMICAL, SAND OR OTHER APPROVED EXTINGUISHING
MATERIAL FOR METAL FIRES.
Fire Fighting Procedures:PROTECTIVE CLOTHING & POSITIVE PRESSURE, SCBA.
Unusual Fire/Explosion Hazard:METAL POWDERS & METAL DUSTS MAY CAUSE
CATALYTIC OXIDATION OF FLAMMABLE ORGANIC SOLVENT VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OR VACUUM UP SPILL. PLACE SPILLED
MATERIAL IN METAL SAFETY CAN.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED & STORE
IN COOL, DRY AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AN APPROPRIATE NIOSH APPROVED RESPIRATOR IN
POORLY VENTILATED AREAS.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:APRON OR PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS & FACE AFTER USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROGEN PEROXIDE, METHANOL & FLAMMABLE ORGANIC SOLVENT VAPORS.
Hazardous Decomposition Products:METAL OXIDE FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS OR SENT TO A REFINERY FOR RECOVERY OF PRECIOUS
METALS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COPPER PHTHALOCYANINE BLUE, 249-0535
CAGE:91686
CAGE:91686
============= Composition/Information on Ingredients =============
Ingred Name:BLUE PIGMENT; (COPPER PHTHALOCYANINE BLUE)
CAS:147-14-8
Fraction by Wt: 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORL,RAT) 10 G/KG OR GREATER
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: SHOULD BE AVOIDED BY WEARING AN
APPROVED DUST MASK. NUISANCE DUST MAY CAUSE RESP IRRITATION. SKIN:
UNDER NORMAL CNDTNS OF GOOD INDUS HYGIENE, NOT EXPECTED TO BE AN
IRRITANT. NOT EXPECTED TO BE ABSORBED THRU SKIN. EYE: SHOULD BE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: PARTICULATE MAY CAUSE EYE IRRITATION.
INGEST: CONSIDERED TO BE PRACTICALLY NON-TOXIC.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY WITH COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. IF IRRITATION PERSISTS, CONSULT MD. SKIN: WASH
WITH SOAP AND WATER. IF SYMPTOMS OCCUR, CONSULT MD. INHAL: REMOVE
TO CLEAN, FRESH AIR AND TREAT SYMPTOMATICALLY. INGEST: INDUCE
VOMITING AND TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:CO*2, DRY CHEMICAL OR FOAM RECOMMENDED.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:IMPROPER HANDLING MAY LEAD TO DUST CLOUD
FORMATION WHICH, AS WITH ANY ORGANIC COMPOUND, MAY BE AN EXPLOSION
HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:PIGMENT SPILLAGE SHOULD BE CLEANED UP AT ONCE.
DRY POWDER SPILLAGE IS OFTEN BEST TREATED FIRST BY DILUTING W/SAND
OR OTHER INERT MATLS PRIOR TO SWEEP-UP. VACUUM SWEEPERS ARE REC.
AIRBORNE ORGANIC DUST MAY BE A DUST EXPLO HAZ; SECURE (SEE SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:A MODERATELY COOL, DRY,
WELL-VENTILATED AREA IS CONSIDERED ADEQUATE FOR THE STORAGE OF
PIGMENT CONTAINERS.
Other Precautions:DIRECT SOURCES OF HEAT MUST BE AVOIDED AND OPEN
CONTAINERS MUST NOT BE ALLOWED TO STAND OVER EXTENDED PERIODS OF
TIME. POSITION CONTAINERS SO THAT ANY LABELLING INFORMATION ON THE
CONTAINER IS VISIBLE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUST RESPIRATORS RECOMMENDED
WHEN HANDLING IN AREAS OF PIGMENT DUSTING.
Ventilation:LOCAL EXHAUST VENTILATION OR CONTAINMENT RECOMMENDED TO
CONTROL DUST EXPOSURE.
Other Protective Equipment:IMPERVIOUS CLOTHING SHOULD BE WORN WHEN
GROSS CONTACT IS LIKELY, SUCH AS WHEN CLEANING UP SPILLS OF LARGE
AMOUNTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MP: SUBLIMES AT TEMPERATURES EXCEEDING 300C. HAZ DECOMP PROD: OXIDES,
OR OTHER TOXIC COMPOUNDS, DEPENDING ON THE PIGMENT TYPE. SPILL
PROC: POSSIBLE SOURCES OF IGNITION AND AVOID DUSTING.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:SEE SUPDAT
Spec Gravity:1.55-1.8
Solubility in Water:INSOLUBLE
Appearance and Odor:BRIGHT GREENISH BLUE; NO APPRECIABLE ODOR
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:WHEN INVOLVED IN A FIRE, BURNING
ORGANIC PIGMENTS MAY EVOLVE NOXIOUS FUMES WHICH MAY INCLUDE CO,
NITROUS (SEE SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF THIS MATERIAL MUST BE MADE IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WATERBORNE POLYURETHANE
Kit Part:Y
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:OXO-HEXYL ACETATE (VP = 0.7)
CAS:88230-35-7
Fraction by Wt: 30.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HEXAMETHYLENE DIISOCYANATE (VP = 0.05)
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:HEXAMETHYLENE DIISOCYANATE POLYMER
CAS:822-06-0
Fraction by Wt: 70.0%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:VOC = 2.62 LBS/GL
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION, REDNESS, ITCHING,
BURNING. SKIN: IRRITATION, REDNESS, ITCHING, BURNING. INHAL: NS
DEPRESSION, UNCONSCIOUSNESS, DEATH, HEADACHE, DIZZINESS, NAUSEA,
LOSS OF COORDINATION.
Medical Cond Aggravated by Exposure:ALLERGIC RESPIRATORY & SKIN
REACTION.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR, GET IMMED MED AID. SKIN: WASH
THOROUGHLY W/SOAP & WATER. REMOVE CONTAM CLOTHES, WASH BEFORE
REUSE. EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINUTES, GET MED
AID. INGEST: GET MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:138F,59C
Lower Limits:1.0
Upper Limits:8.0
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT W/SCBA. H2O MAY
BE INEFFECTIVE. USE FOG NOZZLES. USE H2O TO COOL CNTNRS, PREVENT
PRESSURE BUILDUP/AUTOIGNITION/EXPLOSION.
Unusual Fire/Explosion Hazard:CLOSED CONTAINER MAY EXPLODE W/EXTREME
HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITS. VENT AREA. ABSORB.
NEUTRALIZE. AFTER 10 MINUTES, COLLECT IN OPEN CONTAINER. ADD MORE
NEUTRALIZER. WASH SPILL W/SOAP & WATER.
Neutralizing Agent:10% AMONIA HYDROXIDE SOLUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:PEOPLE W/CHRONIC BREATHING PROBLEMS OR
ISOCYANATE SENSITIZATION SHOULD NOT USE PRODUCT. ELIMINATE IGNITS.
BOND/GROUND WHEN TRANSFERRING.
Other Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE. LABEL
CONTAINER. KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE POSITIVE PRESSURE AIR SUPPLIED RESPIRATOR,
NIOSH/MSHA APPROVED, OR PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR. WHEN SANDING: USE DUST/MIST RESPIRATOR, NIOSH/MSHA
APPROVED.
Ventilation:LOCAL EXHAUST PREFERABLE, GENERAL ACCEPTABLE.
Other Protective Equipment:BARRIER CREAM.
Supplemental Safety and Health
MORE INFORMATION ON FILE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:327 TO 349F
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Density:>AIR.
Spec Gravity:1.05
Evaporation Rate & Reference:<ETHER.
Solubility in Water:NA
Percent Volatiles by Volume:36.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOL, AMINES, ISOCYANATE REACTIVE MATERIALS.
Hazardous Decomposition Products:CO, CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:TEST FOR IGNITABILITY. INCINERATE IN APPROVED
FACILITY. DONT INCINERATE CLOSED CONTAINER. DISPOSE IN ACCORDANCE
W/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & STEEL CORROSION RESISTANT COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:501195-4 F113-SC HARDENER
CAGE:EO666
CAGE:00779
CAGE:22835
CAGE:EO666
============= Composition/Information on Ingredients =============
Ingred Name:DI(3-AMINOPROPYL) ETHER
CAS:4246-51-9
RTECS #:ID6475000
Fraction by Wt: <100%
Ingred Name:DIETHYLENETRIAMINE, ETHYLENEDIAMINE, N-(2-AMINOETHYL)
CAS:111-40-0
RTECS #:IE1225000
Fraction by Wt: <100%
Other REC Limits:4 MG/CUM
OSHA PEL:1 PPM (SKIN)
ACGIH TLV:1 PPM (SKIN)
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
Fraction by Wt: <20%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): >500 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SERIOUS BURNS & STRONG
SENSITIZER. INGESTION: SERIOUS BURNS TO MOUTH.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. INHALATION:
REMOVE TO FRESH AIR. INGESTION: NO KNOWN ANTIDOTE. TREAT SYMPTOMS.
INDUCE VOMITING IF LARGE AMOUNTS IS SWALLOWED. OBTAIN MEDICAL
ATTENTION I N ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F
Extinguishing Media:DRY CHEMICAL, CHEMICAL FOAM, CO2, WATER
Fire Fighting Procedures:AVOID BREATHING SMOKE. ADDITION OF WATER MAY
REDUCE FLAME INTENSITY.
Unusual Fire/Explosion Hazard:TOXIC GASES MAY BE LIBERATED; HANDLE AS
COMBUSTIBLE MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT SKIN & EYE CONTACT. SOAK UP IN
ABSORBENT MATERIAL, OR SCRAPE UP, & TRANSFER TO DISPOSAL CONTAINER.
WIPE UP REMAINING RESIDUE W/SOLVENTS, OBSERVING SOLVENT
FLAMMABILITY CAUTIONS, OR USE DETERGE NTS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL PLACE. FOR INDUSTRIAL
USE ONLY. AVOID EYE & SKIN CONTACT & PROLONGED INHALATION OF
VAPORS.
Other Precautions:STORE IN CLOSED CONTAINERS. CHLORINATED COMPOUNDS;
EXOTHERMS WHEN USED TO CURE EPOXY RESIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AIR-SUPPLIED, OR ORGANIC CANISTER, MASK IN
CONFINED AREAS.
Ventilation:LOCAL EXHAUST/MECHANICAL (GENERAL): RECOMMENDED.
Other Protective Equipment:EYE BATH, SAFETY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F
Vapor Pres:<1
Vapor Density:>2
Spec Gravity:1.04
Solubility in Water:SLIGHT
Appearance and Odor:BLUE, LOW VISCOSITY LIQUID, AMMONIACAL ODOR.
Percent Volatiles by Volume:<1%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ELEMENTAL METALS CORRODED BY LIQUID AMINES, STRONG ACIDS OR OXIDIZING
AGENTS, CHLORINATED COMPOUNDS
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:NITROGEN OXIDES, ALDEHYDES, CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS HAZARDOUS WASTE ACCORDING TO
LOCAL, STATE, & FEDERAL REGULATIONS. DISPOSAL METHOD CAN BE LAND
BURIAL OR CHEMICAL INCINERATION AS REGULATED BY ALL GOVERNMENTAL
AGENCIES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PETROTECT IX,MIL-C-6173,GRADE 1
CAGE:PENRE
CAGE:PENRE
CAGE:86459
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 37%
OSHA PEL:100 PPM
===================== Hazards Identification =====================
Effects of Overexposure:EYE: BURN/IRRIT. SKIN: IRRIT. VAPORS:
IRRIT,DROWSINESS,PNEUMONIA,COMA. INGESTION: IRRIT GI TRACT
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER 15 MIN,CALL PHYSICIAN. SKIN: WASH WITH
SOAP & WATER,REMOVE CONTAMINATED CLOTHING. INHALATION: REMOVE TO
FRESH AIR,GIVE ARTIF RESP IF NEEDED,CALL MD. INGESTION: DO NOT
INDUCE VOMI TING,CALL A PHYSICAIN.
===================== Fire Fighting Measures =====================
Flash Point:100F/37C (PMCC)
Extinguishing Media:FOAM,DRY CHEMICAL,CARBON DIOXIDE
Fire Fighting Procedures:TREAT AS AN OIL FIRE,WATER ONLY TO COOL
EXPOSED CONTAINERS
Unusual Fire/Explosion Hazard:DENSE SMOKE MAY BE GENERATED WHEN
BURNING,SOLVENT CAN CREATE MODERATE FIRE OR EXPLOSION HAZARD
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE FROM IGNITION SOURCES,SCRAPE MATERIAL
INTO WASTE CONTAINERS,OR ABSORB WITH DRY SAND OR OIL ABSORBENTS.
CLEAN SPILL AREA WITH DETERGENT SOLUTIONS OR SAFETY SOLVENTS.
PROVIDE ADEQUATE VENTILATION DURING CLEAN UP.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN SEALED CONTAINERS AWAY FROM
HEAT,OPEN FLAME,AND OXIDIZING MATERIALS.
Other Precautions:FIRE EXTINGUISHERS MUST BE KEPT READLY AVAILABLE &
PERSONNEL TRAINED IN PROPER USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN
Ventilation:LOCAL/GENERAL
Other Protective Equipment:RUBBER PROTECTIVE CLOTHING,BOOTS,APRONS
Supplemental Safety and Health
50% DISTILLATION TEMPERATURE IS BETWEEN 300-360F. PKG: 55 GAL DRUM.
SOLVENT CONTAINS NO DETECTABLE BENZENE (IE: <3 PPM)
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:300F/148C
Vapor Density:4.3
Spec Gravity:0.912
Evaporation Rate & Reference:<1 (EE)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK LIQUID ASPHALT,HYDROCARBON SOLVENT ODOR
Percent Volatiles by Volume:37
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CO,CO*2,SMOKE,SO*X
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIALS SHOULD BE DUMPED OR BURIED IN AN
APPROVED INDUSTRIAL WASTE LAND FILL. LARGE QUANTITIES MAY BE
DISPOSED OF BY INCINERATION IN A SUITABLE COMBUSTION CHAMBER.
DISPOSAL MUST COMPLY WITH AL L FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-22750E ACTIVATOR ORANGE 12197 PN U3-0
Kit Part:Y
Preparer's Name:DAVID SCHMETTERER
CAGE:DO165
CAGE:DO165
CAGE:5V430
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (SARA III) (VAPOR PRESSURE 71.2 MM HG)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 40%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NONYLPHENOL (CONTAINS A TRACE OF PHENOL, CAS # 108-95-2,
WHICH HAS A TLV VALUE OF 5 PPM) (VAPOR PRESSURE 0.9 MM HG)
CAS:25154-52-3
RTECS #:SM5600000
Fraction by Wt: 15%
Other REC Limits:NONE SPECIFIED
Ingred Name:META XYLENE DIAMINE
CAS:1477-55-0
RTECS #:PF8970000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:0.1 MG/M3
Ingred Name:AMINE ADDUCT
CAS:68738-77-2
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Ingred Name:CRYSTALLINE SILICA
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: <0.1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:RED PIGMENT 48 (PRODUCT CONTAINS PROPRIETARY AMOUNT OF
MANGANESE CAS # 7439-96-5)
CAS:5280-66-0
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Ingred Name:SILICON DIOXIDE (MAY BE RELEASED BY SANDING DRIED PAINT
FILM.
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:VOC: 464 GPL.
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:OVEREXPOSURE: ACUTE TOXICITY,
RESULTING IN HEADACHE, DIZZINESS, NAUSEA, LOSS OF CONSCIOUSNESS.
SEVERE EYE IRRITATION POSSIBLY RESULTING IN PERMANENT DAMAGE.
IRRITATED MUCOUS MEMBRANES. VOMITING DUE TO INGESTION. DEFATTING
AND DRYING OF THESKIN. SENSITIZATION AFTER REPEATED CONTACT.
Explanation of Carcinogenicity:THERE IS LIMITED EVIDENCE OF
CARCIOGENICITY OF CRYSALLINE SILICA TO HUMANS.
Effects of Overexposure:IF SANDING DRIED FILM, PROLONGED OVEREXPOSURE
TO DUST BY INHALATION MAY CAUSE DELAYED LUNG INJURY/DISEASE
(SILICOSIS).
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/CLEAN LUKEWARM LOW PRESSURE WATER 15 MIN,
LIFTING EYELIDS. GET MED AID. INHAL: REMOVE TO FRESH AIR. PROVIDE
OXYGEN IF BREATHING DIFFICULT. GIVE ARTIF RESPIRATION IF NOT
BREATHING. GET MEDAID. KEEP WARM & COMFORTABLE. NEVER GIVE
UNCONSCIOUS PERSON LIQUIDS. INGEST: CALL DR. INDUCE VOMIT ONLY ON
INSTRUCT OF DR. IF VOMIT OCCURS, KEEP HEAD BELOW HIPS (PREVENT
ASPIRATION OF LIQ INTO LUNG)*
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:22.0F,-5.6C
Lower Limits:2
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL.
Fire Fighting Procedures:USE WATER TO KEEP EXPOSED CONTAINERS COOL, &
TO KEEP FLAMMABLE STRUCTURES WET. DO NOT ENTER FIRE AREA W/O
PROTECTION BECAUSE HAZARD DECOMP PROD MAY BE PRESENT.
Unusual Fire/Explosion Hazard:WATER PRESSURE MAY SPREAD A FLAMMABLE
LIQUID FIRE. SEALED CONTAINERS MAY EXPLODE IF OVERHEATED.
================== Accidental Release Measures ==================
Spill Release Procedures:WARNING - FLAMMABLE. ELIMINATE ALL IGNITION
SOURCES. HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING.
SOAK UP W/ABSORBENT & PLACE IN NON-LEAKING CONTAINERS. SEAL TIGHTLY
FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:HAZARD-FLAMMABLE. KNOW DOT REGS BEFORE
TRANSPORTING. WARNING: HOT ORGANIC CHEMICAL VAPORS/MISTS MAY
SPONTANEOUSLY COMBUST WHEN MIXED W/AIR.
Other Precautions:IGNITION MAY OCCUR AT TEMPS BELOW PUBLISHED
AUTOIGNIT/IGNIT TEMPS. IGNITION TEMPS DECREASE W/INCREASING VAPOR
VOLUME & VAPOR/AIR CONTACT TIME & ARE INFLUENCED BY PRESSURE
CHANGES. IGNIT MAY OCCUR AT T YPICAL ELEVATED TEMP PROCESS
CONDITION**
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IMPORTANT-MUST PROVIDE VENT TO MAINTAIN VAPOR
CONCENTRATIONS BELOW ESTABLISHED OSHA TLV LIMIT. IN CONFINED AREAS
NIOSH/MSHA RESPIRATOR EQUIPPED WITH ORGANIC VAPOR CARTRIDGE SHOULD
BE WORN.
Ventilation:MUST PROVIDE VENTILATION.
Other Protective Equipment:HAVE EYE BATH AND SAFETY SHOWER AVAILABLE.
Supplemental Safety and Health
**ESP IN PROCESS OPERATING UNDER VACUUM IF SUBJECTED TO SUDDEN INGRESS
OF AIR/OUTSIDE PROCESS EQUIP OPERATING UNDER ELEVATED PRESSURE IF
SUDDEN ESCAPE OF VAPORS/MISTS TO ATMOSPHERE OCCURS. PROPOSED US E
OF PROD IN ELEVATED TEMP PROCESSES SHOULD BE EVALUATED TO ASSURE
SAFE OPERATING CONDITIONS ESTABLISHED/MAINTAINED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:174 TO 567F
Vapor Density:> AIR.
Spec Gravity:1.14
Viscosity:>200 CENTI
Evaporation Rate & Reference:4.61 X N-BUTYL ACETATE
Solubility in Water:SLIGHT
Appearance and Odor:ORANGE LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:57.7
Corrosion Rate:NOT CORR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY BE INCOMPATIBLE WITH OXIDIZING AGENTS AND STRONG ALKALIES.
Stability Condition to Avoid:AVOID HEAT, SPARKS, OPEN FLAMES, AND
INCOMPATIBILITIES.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION FOR PRODUCTS
LIKE THIS MAY GENERATE HIGHLY POISONOUS CARBON MONOXIDE AND OTHER
TOXIC GASES.
Conditions to Avoid Polymerization:AVOID HEAT, SPARKS, OPEN FLAMES, AND
INCOMPATIBILITIES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORD W/LOCAL, STATE & FED
REGS. CONTACT APPRV'D DISPOSAL FACILITY. EPA HZD # D001, IGNITABLE.
* SKIN: FLUSH W/WATER WHILE REMOVING CONTAM
CLOTH, SHOES. WA SH W/SOAP & WATER. IF IRRIT PERSISTS, GET MED AID.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ATOM ARC COVERED LOW HYDROGEN ELECTRODE
CAGE:84021
CAGE:84021
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-86-6
RTECS #:NO6925000
Other REC Limits:NONE RECOMMENDED
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SODIUM METASILICATE, ANHYDROUS
CAS:6834-92-0
RTECS #:VV9275000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3 8HR
ACGIH TLV:C; 2 MG.M3
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9293
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:POTASSIUM SILICATE
CAS:1312-76-1
Other REC Limits:NONE RECOMMENDED
Ingred Name:CALCIUM FLUORIDE
CAS:7789-75-5
RTECS #:EW1760000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2.5 MG/M3 AS F
ACGIH TLV:2.5 MG/M3 AS F
Ingred Name:POTASSIUM ALUMINUM SILICATE (FELDSPAR)
CAS:68476-25-5
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:2 MG/M3
Ingred Name:ZIRCONIUM SILICATE
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV: 5 MG/M3 WELDING FUME
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:FUMES AND GASES CAN BE DANGEROUS TO
YOUR HEALTH. ACUTE: OVEREXPOSURE TO WELDING FUMES MAY RESULT IN
DISCOMFORT SUCH AS IRRITATION OF NOSE, THROAT OR EYES. CHRONIC:
OVEREXPOSURE MAY LEAD TO SIDEROSIS ( IRON DEPOSITS IN THE LUNG) AND
IS BELIEVED BY SOME INVESTIGATORS TO AFFECT PULMONARY FUNCTION.
Explanation of Carcinogenicity:CHROMIUM & NICKEL ARE BOTH REGULATED BY
NTP & IARC. CHROMIUM IS REGULATED BY OSHA.
Effects of Overexposure:OVEREXPOSURE TO WELDING FUME MAY RESULT IN
DIZZINESS, NAUSEA, OR DRYNESS. ARC RAYS CAN INJURE EYES AND BURN
SKIN. ELECTRIC SHOCK CAN KILL.
Medical Cond Aggravated by Exposure:AGGRAVATION OF PREEXISTING
RESPIRATORY OR ALLERGIC CONDTIONS MAY OCCUR IN SOME WORKERS.
======================= First Aid Measures =======================
First Aid:CALL FOR MEDICAL AID. EMPLOY FIRST AID TECHNIQUES RECOMMENDED
BY THE AMERICAN RED CROSS.
===================== Fire Fighting Measures =====================
Extinguishing Media:NONE SPECIFIED BY MANUFACTURER.
Fire Fighting Procedures:NONFLAMMABLE.
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS CAN IGNITE
COMBUSTIBLES. SEE Z-49.1 REFERENCED IN SECTION VII.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:TRAIN THE WELDER NOT TO TOUCH LIVE ELECTRICAL PARTS
AND TO INSULATE HIMSELF FROM WORK AND GROUND.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN HANDLING IN CONFINED SPACE OR WHERE LOCAL EXHAUST
OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:USE ENOUGH VENTILATION, LOCAL EXHAUST AT THE ARC, OR BOTH,
TO KEEP THE FUMES AND GASES BELOW THE TLV'S IN BREATHING ZONE
Other Protective Equipment:WEAR HEAD, HAND & BODY PROTECTION WHICH HELP
TO PREVENT INJURY FROM RADIATION, SPARKS & ELECTRICAL SHOCK. SEE
ANSI Z-49.
Work Hygienic Practices:TRAIN THE WELDER NOT TO TOUCH LIVE ELECTRICAL
PARTS AND TO INSULATE HIMSELF FROM WORK AND GROUND.
Supplemental Safety and Health
TRAIN WELDER TO KEEP HEAD OUT OF FUMES. PROVIDE PROTECTIVE SCREENS AND
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:ATOM ARC COVERED LOW HYDROGEN ELECTRODES.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES CANNOT BE CLASSIFIED
SIMPLY. THEIR COMPOSITION ARE BASED ON THE METAL, PROCESS,
PROCEDURE & ELECTROD USED.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER, OR
LINER IN AN ENVIRNMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
WITH FEDERAL, STATE AN D LOCAL REGULATION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ALGAEZONE, PLUS, 42177-44
CAGE:YORKC
CAGE:YORKC
CAGE:94683
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2,2',2"-NITRILOTRI-, COPPER SALT;
(COPPER-TRIETHANOLAMINE COMPLEX)
CAS:31089-39-1
RTECS #:KL9282000
Fraction by Wt: 37.5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT):GREATER THAN 470 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NON IRRITATING TO EYES AND SKIN.
MINIMAL HAZARD FROM INHALATION. HIGHLY EMETIC, VERY SELDOM TOXIC.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN:WASH WITH
SOAP AND WATER. SEEK MEDICAL ATTENTION IF IRRITATION PERSISTS.
INHAL:REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. G ET MEDICAL ATTENTION. INGEST:DRINK 1-2 GLASSES OF
WATER AND INDUCE VOMITING. CONTACT PHYSICIAN. DO NOT INDUCE
VOMITING OR ADMINISTER ANYTHING ORALLY TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL. TAKE UP W/ABSORBENT MATERIAL
AND PLACE IN CHEMICAL WASTE CONTAINERS. SEAL FOR DISPOSAL. WASH
SPILL AREA WITH WATER CONTAINING A STRONG DETERGENT, ABSORB, AND
PLACE IN CHEMICAL WASTE CON TAINER FOR DISPOSAL. FLUSH SPILL AREA
WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY AREA BELOW 35C.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUAL CARTRIDGE RESPIRATOR
FOR DUST AND MISTS.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPEC GRAV:1.18-1.21 (H*2O=1).
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:225F,107C
Spec Gravity:SUPP DATA
Solubility in Water:COMPLETE
Appearance and Odor:DARK BLUE LIQUID, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING ACIDS
Stability Condition to Avoid:CONTAMINATION, FREEZING, HIGH TEMPERATURES
Hazardous Decomposition Products:DECOMPOSES ABOVE 200C
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE SHIPPED TO A CHEMICAL DUMP OR DISPOSED OF
IN A MANNER IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SURGILUBE
CAGE:23301
CAGE:23301
============= Composition/Information on Ingredients =============
Ingred Name:PROPYLENE GLYCOL
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
Ingred Name:PROPYLENE OXIDE (SARA III)
CAS:75-56-9
RTECS #:TZ2975000
Fraction by Wt: <0.025%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:20 PPM; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION-NOT LIKELY DUE TO THE
PHYSICAL STATE OF THE PRODUCT. EYES-MAY CAUSE SLIGHT IRRITATION.
SKIN-NONE EXPECTED UNDER NORMAL CONDITION OF USE. INGESTION-MAY
CAUSE MILD NAUSEA AND/OR VOMITING. CHR ONIC-MAY PRODUCE ALLERGIC
RESPONSES IN SENSITIVE INDIVIDUALS.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:PRACTICALLY NON-TOXIC.
Medical Cond Aggravated by Exposure:IRRITATION OF THE SKIN IN SENSITIVE
INDIVIDUALS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYES WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST
15 MIN. SKIN: WASH WITH PLENTY OF WATER. INGESTION: GIVE TWO
GLASSES OF WATER AND INDUCE VOMITING. NEVER GIVE ANYTHING TO AN
UNCONSCIOUS PER SON. INHALATION: REMOVE TO FRESH AIR. IF BREATHING
IS DIFFICULT, GIVE OXYGEN.
===================== Fire Fighting Measures =====================
Flash Point:NOT DETERMINED
Autoignition Temp:Autoignition Temp Text:N/D
Lower Limits:N/D
Upper Limits:N/D
Extinguishing Media:ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:AVOID MIXING WITH STRONG OXIDIZERS AND
SOURCES OF HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:ASSURE SLIPPERY CONDITIONS ARE NULLIFIED. ADD
SAND OR DIRT. SCOOP UP AND REMOVE. DISPOSE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN MATERIAL
IS NOT IN USE. DO NOT HANDLE OR STORE NEAR HEAT, FLAME OR
OXIDIZERS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:GENERAL VENTILATION.
Ventilation:USE GENERAL VENTILATION TO PROTECT YOUR LUNGS.
Other Protective Equipment:AS NEEDED TO PREVENT REPEATED/PROLONGED
CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. USE NORMAL
HYGIENE TO PROTECT HANDS, EYES & SKIN.
Supplemental Safety and Health
DO NOT WEAR CONTAINMATED CLOTHING UNTIL THOROUGHLY LAUNDERED.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.0
pH:4-7
Viscosity:150-1000 CPS
Evaporation Rate & Reference:0.02 (DIETHYL ETHER)
Solubility in Water:DISPERSES
Appearance and Odor:ESSENTIALLY ODORLESS, SMOOTH, TRANSLUCENT GEL THAT
HAS A SLIGHT LAVENDAR ODOR.
Percent Volatiles by Volume: 85%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:HEAT, FLAMES.
Hazardous Decomposition Products:MAY EMIT TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:ASSURE CONFORMITY WITH APPLICABLE DISPOSAL
REGULATIONS. DISPOSE OF ABSORBED MATERIAL AT APPROVED INCINERATION
OR CHEMICAL LANDFILL WASTE DISPOSAL SITE.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:CALSTOM PERLITE (ALL GRADES)
Resp. Party Other MSDS Num.:REV. NO. 2
Preparer's Name:PATRICK T. FLYNN, JR
CAGE:0PXU6
CAGE:0PXU6
============= Composition/Information on Ingredients =============
Ingred Name:PERLITE; ( 5 MG/M3 RESPIRABLE DUST)
CAS:93763-70-3
RTECS #:SD5254000
= Wt:100.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PERLITE IS A NATURALLY OCCURRING
VOLCANIC GLASS CONSISTING OF FUSED SODIUM - POTASSIUM - ALUMINUM
SILICATE. TESTS CONDUCTED ON CELATOM PERLITE HAVE NOT IDENTIFIED
CRYSTALLINE SILICA AS BEING PRESENT A BOVE THE DETECTION LIMIT
(0.05%). ALTHOUGH THERE ARE NO PUBLISHED REPORTS OF ADVERSE HEALTH
EFFECTS FROM EXPOSURE TO PERLITE DUST, DUST LEVELS SHOULD BE
MAINTAINED BELOW THE OSHA PERMISSIBLE EXPOSURE LIMITS FOR PERLITE
AND RESPIRATORS USED WHEN AIRBORNE DUST IS PRESENT. ACUTE: UPPER
RESPIRATORY IRRITANT - MAY CAUSE COUGHING OR THROAT IRRITATION.
CHRONIC: ALTHOUGH THERE ARE NO REPORTS TO ADVERSE HE ALTH EFFECTS
(EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZS: FROM EXPOSURE TO PERLITE DUST,
INHALATION OF HIGH CONCENTRATIONS OF PERLITE DUST OR ANY OTHER
PARTICULATES, FOR PROLONGED PERIODS OF TIME MAY CAUSE LUNG DAMAGE.
NOT LISTED AS A CARCINOGEN B Y IARC, NTP OR OSHA.
Medical Cond Aggravated by Exposure:PRE-EXISTING DISEASES OF THE UPPER
RESPIRATORY TRACT AND LUNG SUCH AS BRONCHITIS, EMPHYSEMA AND
ASTHMA.
======================= First Aid Measures =======================
First Aid:SKIN: NOT ABSORBED BY THE SKIN. MAY CAUSE DRYNESS. USE
MOISTURE RENEWING LOTIONS IF DRYNESS OCCURS. EYE: MAY CAUSE
IRRITATION OR INFLAMMATION. WASH WITH GENEROUS QUANTITIES OF WATER
FOR AT LEAST 15 MI NUTES. CONSULT PHYSICIAN IF IRRITATION PERSISTS.
INHALATION: ACUTE INHALATION CAN CAUSE DRYNESS OF THE NASAL
PASSAGES AND CONGESTION OF THE UPPER RESPIRATORY TRACT. REMOVE TO
FRESH AIR. INGESTION: SHO RT-TERM EXPOSURE NOT CONSIDERED HARMFUL.
DRINK GENEROUS AMOUNTS OF WATER TO REDUCE BULK AND DRYING EFFECTS.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . NOT
APPLICABLE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . NOT APPLICABLE.
Unusual Fire/Explosion Hazard:FLAMMABILITY: NO.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM CLEAN SPILLAGE, WET SWEEP OR WASH AWAY.
AVOID CREATING DUST.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CREATING DUST. REPAIR OR
PROPERLY DISPOSE OF BROKEN BAGS. STORE IN A DRY PLACE TO MAINTAIN
PRODUCT QUALITY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ADEQUATE PROTECTIVE DEVICES, SUCH AS NIOSH
APPROVED RESPIRATORS APPROVED FOR MINERAL DUSTS, SHOULD BE WORN
WHEN AIRBORNE DUST IS PRESENT. NIOSH APPROVED RESPIRATORS INCLUDE
3M (TM) 9900 AND MAS (TM) D USTFOE 86.
Ventilation:LOCAL - CONTROL W/IN RECOM TLV/PEL. REFER TO ACGIH PUB
"INDUSTRIAL VENTILATION" OR SIMILAR PUBLICATIONS FOR DESIGN OF
VENTILATION SYSTEMS.
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
FOOTWEAR: NOT NECESSARY. CLOTHING: NOT NORMALLY NECESSARY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:2.3
pH:NEUTRAL
Solubility in Water:NIL
Appearance and Odor:ODORLESS, WHITE POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID. PRODUCTS CONTAINING SILICA/SILICATE MAY REACT
VIOLENTLY WITH HYDROFLUORIC ACID.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:NON-BIODEGRADABLE. USE SOLID WASTE DISPOSAL
COMMON TO LANDFILL TYPE OPERATIONS IN A SLURRY TO SUMPS. NOT
CONSIDERED A HAZARDOUS WASTE UNDER RCRA (40 CFR PART 261).
=================== MSDS Transport Information ===================
Transport Information:SPECIAL SHIPPING INSTRUCTIONS: NONE.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KODAK DEKTOL DEVELOPER (SINGLE POWDER), WORKING SOLUTION
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 90-95%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:SODIUM CARBONATE
CAS:497-19-8
RTECS #:VZ4050000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:P-METHYLAMINOPHENOL SULFATE (METOL)
CAS:55-55-1
RTECS #:SL8650000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: EXPECTED TO BE A LOW
HAZARD FOR RECOMMENDED HANDLING. EYES: CAUSES IRRITATION. SKIN:
CAUSES IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION. INGESTION:
EXPECTED TO BE A LOW INGESTION HAZARD.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION-IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSISTS. EYES-IMMEDIATELY FLUSH WITH PLENTY
OF WATER FOR AT LEAST 15 MIN. GET MEDICAL ATTENTION. SKIN-
IMMEDIATELY FLUS H WITH PLENTY OF WATER & WASH WITH A NON-ALKALINE
SKIN CLEANER. GET MEDCIAL ATTENTION. INGESTED-DRINK 1 TO 2 GLASSES
OF WATER. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE APPROPIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER ABSORBENT, THEN
PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY
TO REMOVE RESIDUAL CONTA MINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED.
Other Precautions:AVOID CONTACT WITH EYES, SKIN & CLOTHING. USE WITH
ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (10 AIR CHANGES PER HOUR) SHOULD
BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS.
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:24 MBAR
Vapor Density:0.6
Spec Gravity:1.04-1.06
pH:10.2
Evaporation Rate & Reference:0.4 (N-BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, LIGHT YELLOW, ODORLESS.
Percent Volatiles by Volume:90-95
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINANTS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:0835244000, ISE INTERNAL REFERENCE SOLUTION
Preparer's Name:EILEEN MEULBROEK
CAGE:51169
CAGE:51169
============= Composition/Information on Ingredients =============
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: <5%
Ingred Name:SUPDAT:WORKING W/THESE REAGENTS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXICOLOGICAL EFFECTS OF FINISHED
PRODUCT HAVE NOT BEEN THOROUGHLY INVESTIGATED AT THIS TIME. THIS
SOLUTION MAY CAUSE SKIN & EYE IRRITATION & MAY BE HARMFUL BY
INHALATION, INGESTION OR ABSORPTION. BOR IC ACID EXPOSURE CAN CAUSE
IRRITATION, CYANOSIS, VOMITING & DIARRHEA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NO INFORMATION.
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH W/LG AMTS OF FRESH WATER FOR AT LST 15 MINS.
HOLD EYELIDS APART W/YOUR FINGERTIPS TO ENSURE COMPLETE FLUSH. GET
MED ASSISTANCE. SKIN:WHILE REMOVING CONTAM CLTHG, FLUSH AFFECTED
BODY AR EA W/LG AMTS OF FRESH WATER. CONTINUE FLUSH FOR AT LST 15
MINS. DO NOT REUSE CONTAM CLTHG UNTIL WASHED & RINSED. SEEK MED
ASSISTANCE. INGEST:KEEP VICTIM WARM & CALM. IF VICTIM IS ABLE, GIVE
LG(SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA AS APPROPRIATE FOR SITE SPECIFIC
CONDITIONS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NO SPECIFIC DATA.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. CONTAIN & CLEAN UP SPILL USING
ABSORBENT MATERIAL. ONCE ABSORBED, PLACE "SPENT ABSORBENT" IN
SUITABLE CONTAINER & CLOSE LID. HOLD MATERIAL FOR APPROPRIATE
DISPOSAL. ONCE SPILL PICK UP IS COMPLETE, RINSE AREA W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. STORE IN A
SEALED CONDITION.
Other Precautions:USE GOOD LABORATORY TECHNIQUE WHEN HANDLING THIS
PRODUCT. DO NOT MOUTH PIPETTE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST.
Ventilation:USE ADEQUATE GENERAL ROOM VENTILATION.
Other Protective Equipment:EYEWASH & DELUGE SHOWER SHOULD BE AVAILABLE.
LAB COAT SHOULD BE WORN.
Work Hygienic Practices:OBSERVE APPROP CHEM HYGIENE. UPON COMPLETION OF
WORK ACTIVITIES INVOLVING THIS PROD, WASH ANY EXPOSED BODY
AREAS(SUPDAT)
Supplemental Safety and Health
MFR'S TRADE NAME: USE WITH BM/HITACHI ANALYZERS. FIRST AID PROC:AMTS OF
WATER. OBTAIN IMMED MED HELP. INHAL:REMOVE VICTIM TO FRESH AIR. IF
BREATHING IS LABORED, GIVE OXYGEN. IF BREATHING STOPS, GIVE A RTF
RESP. GET PROMPT MED ATTN. HYGIENE PRACT:(I.E. HANDS) THORO W/SOAP
& WATER. DO NOT EAT, DRINK/SMOKE WHILE (ING 2)
================== Physical/Chemical Properties ==================
Solubility in Water:SOLUBLE
Appearance and Odor:AQUEOUS SOLUTION.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO INFORMATION FOR FINAL PRODUCT. BORIC ACID IS INCOMPATIBLE W/ALKALI
CARBONATES & HYDROXIDES.
Stability Condition to Avoid:EXCESS HEAT, FLAMES OR PRESSURE.
Hazardous Decomposition Products:NO INFORMATION FOR FINAL PRODUCT.
BORIC ACID DECOMPOSITION PRODUCTS INCLUDE BORON OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NOX RUST X110 MIL-C-16173 E, CLASS1, GRADE 4
Preparer's Name:ERNEST CARTER
CAGE:7X108
CAGE:7X108
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC PETROLEUM SOLVENT
CAS:64742-88-7
Code:F
Minumum % Wt:41.
Maxumum % Wt:44.
Ingred Name:PETROLEUM HYDROCARBON DISTILLATE
CAS:8008-20-6
Code:F
RTECS #:OA5500000
< Wt:5.
Ingred Name:OXIDIZED ALIPHATIC PETROLEUM FRACTION
CAS:64743-01-7
Minumum % Wt:40.
Maxumum % Wt:44.
Ingred Name:PETROLEUM OIL
< Wt:5.
Ingred Name:CALCIUM HYDROXIDE
CAS:1305-62-0
RTECS #:EW2800000
< Wt:5.
OSHA PEL:15 MG/M3
ACGIH TLV:5 MG/M3
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXCESSIVE INHALATION MAY PRODUCE
DIZZINESS. NAUSEA, HEADACHE, AND INCOORDINATION. MAY CAUSE SEVERE
EYE IRRITATION AND REVERSIBLE SKIN IRRITATION. PROLONGED SKIN
EXPOSURE MAY CAUSE DERMATITIS OR OIL A CNE. BREATHING MISTS MAY
CAUSE DIZZINESS OR PULMONARY IRRITATION.
Explanation of Carcinogenicity:NONE OF THE COMPONENTS OF THIS PRODUCTS
ARE LISTED AS CARCINOGENS BY NTP, IARC, OR OSHA 1910(Z).
Medical Cond Aggravated by Exposure:EXPOSURE MAY AGGRAVATE PRE-EXISTING
RESPIRATORY OR SKIN PROBLEMS.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE VICTIM TO FRESH AIR AND CALL EMERGENCY
MEDICAL CARE. EYES: IMMEDIATELY FLUSH EYES WITH RUNNING WATER FOR
AT LEAST 15 MINUTES. SEEK IMMEDIATE MEDICAL ATTENTION.SKIN:
WASH SKIN WI TH SOAP AND WATER. REMOVE AND ISOLATE CONTAMINATED
CLOTHING AND SHOES AT THIS SITE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=40.6C, 105.F
Lower Limits:0.6%
Upper Limits:7.0%
Extinguishing Media:SMALL FIRES: DRY CHEMICAL, CO2, WATER SPRAY, OR
REGULAR FOAM. LARGE FIRES: WATER SPRAY, FOG, REGULAR FOAM.
Fire Fighting Procedures:FIRE MAY PRODUCE IRRITATING OR POISONOUS
GASES. POSITIVE PRESSURE SELF-CONTAINED BREATHING APPARATUS (SCBA)
AND STRUCTURAL FIREFIGHTERS? PROTECTIVE CLOTHING WILL PROVIDE
LIMITED PROTECTION. COOL CONT AINERS THAT HAVE BEEN EXPOSED TO
HEAT. IF IN CARGO AREA, USE UNMANNED HOSE HOLDER OR WITHDRAW AND
LET FIRE BURN.
Unusual Fire/Explosion Hazard:VAPORS MAY TRAVEL TO A SOURCE OF IGNITION
AND FLASH BACK. CONTAINER MAY EXPLODE IN HEAT OF FIRE. RUNOFF TO
SEWER MAY CREATE EXPLOSION OR FIRE HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF IGNITION SOURCES, NO FLARES, SMOKING
OR FLAMES IN HAZARD AREA. STOP LEAK IF YOU CAN DO IT WITHOUT
RISK.SMALL AND LARGE SPILLS: TAKE UP WITH SAND OR OTHER
NONCOMBUSTIBLE ABSORBENT MATERIAL AND PLACE INTO CONTAINERS FOR
LATER DISPOSAL. LARGE SPILLS: DIKE SPILL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, WELL-VENTILATED AREA.
KEEP AWAY FROM FLAMES, SPARKS OR HOT SURFACES. NEVER USE A TORCH TO
CUT OR WELD ON OR NEAR CONTAINER. EMPTY CONTAINERS CAN CONTAIN
EXPLOSIVE VAPORS.
Other Precautions:NEVER WEAR CONTAMINATED CLOTHING. LAUNDER OR DRY
CLEAN BEFORE WEARING. DISCARD OIL-SOAKED SHOES.WASH THOROUGHLY WITH
SOAP AND WATER (WATERLESS HAND CLEANER MAY BE HELPFUL IN REMOVING
RESIDUES) AFTER U SE AND BEFORE SMOKING OR EATING. AVOID EXCESSIVE
SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH-APPROVED RESPIRATOR FOR ORGANIC VAPOR AND
MIST TO CONTROL EXPOSURE WHERE VENTILATION IS INADEQUATE.
Ventilation:GENERAL AND LOCAL EXHAUST.
Other Protective Equipment:IF SPLASHING IS ANTCIPATED, WEAR RUBBER
APRON AND BOOTS OR OTHER PROTECTIVE EQUIPMENT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=148.9C, 300.F
Vapor Pres:3.4
Vapor Density:>1
Spec Gravity:0.88
Evaporation Rate & Reference:<1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:VISCOUS LIQUID PETROLEUM SOLVENT DARK
Percent Volatiles by Volume:60%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF SULFUR, MISCELLANEOUS, HYDROCARBONS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH STATE, LOCAL AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:03BK092CAT; COMP B, 1-COAT, 17038
Kit Part:Y
CAGE:FO129
CAGE:FO129
CAGE:33461
============= Composition/Information on Ingredients =============
Ingred Name:VOL ORGANIC CMPD: 510 G/L
RTECS #:9999999VO
Ingred Name:WEIGHT PER GALLON IN POUNDS: 7.78
RTECS #:9999999WG
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 15%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALIPHATIC POLYISOCYANATE, HEXAMETHYLENE DIISOCYANATE
POLYMER (HDI POLYMER)
CAS:28182-81-2
RTECS #:NQ9170000
Fraction by Wt: 45%
Other REC Limits:1 MG/CUM
Ingred Name:HEXAMETHYLENE DIISOCYANATE
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: <.5-1.6%
ACGIH TLV:.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:HEXONE, METHYL ISOBUTYL KETONE (MIBK), 4-METHYL-2-PENTANONE
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 40%
Other REC Limits:50 PPM
OSHA PEL:410 MG/CUM
ACGIH TLV:205 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF RESPIRATORY
TRACT/CNS DEPRESSION/POSSIBLE UNCONSCIOUSNESS/COMA. ISCYANATE
SENSITIZATION. SKIN: IRRITATION/ABSORPTION. EYES: IRRITATION.
INGESTION: IRRITATION & POSSIBLE CORRO SIVE ACTION IN THE
MOUTH/STOMACH TISSUE/DIGESTIVE TRACT. ALLERGIC REACTION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE/DIZZINESS/STAGGERING
GAIT/CONFUSION/UNCONSCIOUSNESS/COMA/DIFFICULT BREATHING. SKIN:
SWELLING/REDNESS/RASH/DRYING/DEFATTING/CRACKING. EYES:
TEARING/REDNESS/SWELLING/STINGING SENSAT ION. INGESTION: VOMITING
MAY CAUSE ASPIRATION OF SOLVENTS, RESULTING IN CHEICAL PNEUMONITIS.
Medical Cond Aggravated by Exposure:ASTHMA, RESPIRATORY DISORDERS, SKIN
ALLERGIES, ECZEMA, DERMATITIS, ISOCYANATE SENSITIZATION
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. SKIN:
REMOVE CONTAMINATED CLOTHING. WASH AFFECTED AREAS THOROUGHLY W/SOAP
& WATER. EYES: FLUSH W/CLEAN LUKEWARM WATER (LOW PRESSURE) FOR 15
MINUTES. INGESTION: DON'T INDUCE VOMITING. DON'T GIVE ANYTHING TO
AN UNCONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:45F
Lower Limits:1%
Upper Limits:8%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WEAR SCBA/FULL PROTECTIVE CLOTHING. USE WATER
TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE
BUILD-UP/AUTOIGNITION/EXPLOSION.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION. VENTILATE AREA. CONTAIN & REMOVE W/INERT
ABSORBENT & NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORE NEAR IGNITION SOURCES.
STORE IN TIGHTLY CLOSED CONTAINERS. STORE IN WELL VENTILATED AREAS.
KEEP CONTAINERS TIGHT/UPRIGHT TO PREVENT LEAKS.
Other Precautions:AVOID VAPOR/SPRAY MIST INHALATION. AVOID SKIN/EYE
CONTACT. DON'T INGEST. DON'T HANDLE UNLESS SAFETY PRECAUTIONS ARE
READ/UNDERSTOOD. SMOKE IN SMOKING AREAS ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE IN ORGANIC VAPOR ENVIRONMENT (AIR PURIFYING
OR FRESH AIR SUPPLIED) IS NECESSARY. AN AIR SUPPLIED RESPIRATOR IS
RECOMMENDED. A VAPOR PARTICULATE RESPIRATOR MAY BE APPROPRIATE
WHERE AIR MONITORING D EMONSTRATES VAPOR LEVEL 10 TIMES LIMIT.
Ventilation:EXHAUST SUFFICIENT TO KEEP AIRBORNE CONCENTRATIONS OF
SOLVENT BELOW THEIR TLVS.
LONG LEG CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING, SMOKING, OR USING WASHROOM.
Supplemental Safety and Health
FREE MONOMER CONTENT LESS THAN 0.5% BASED ON RESIN SOLIDS AT THE TIME
OF MANUFACTURE. HOWEVER, AFTER 3-6 MONTHS STORAGE, THE FREE MONOMER
CONTENT MAY RISE TO A MAXIMUM OF 1.6%
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:230-460F
Vapor Density:>1
Spec Gravity:0.93397
Evaporation Rate & Reference:(N-BU AC = 1): 1.39
Solubility in Water:INSOLUBLE
Appearance and Odor:THIS LIQUID TO HEAVY VISCOUS MATERIAL; AMBER LIQUID
W/SOLVENT ODOR.
Percent Volatiles by Volume:60.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER/AMINES/STRONG BASES/ALCOHOL/METAL COMPOUND/SURFACE ACTIVE
MATERIAL/MATERIAL THAT REACT W/ISOCYANATES
Stability Condition to Avoid:ELECTRICAL EQUIPMENT, HOT SURFACES,
EXTREME HEAT, & OTHER SOURCES OF IGNITION, MOISTURE
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN, TRACES OF
HYDROGEN CYANIDE & HEXAMETHYLENE DIISOCYANATE
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MUST BE DISPOSED OF IAW/LOCAL, STATE, &
FEDERAL REGULATIONS. EMPTY CONTAINERS MUST BE HANDLED W/CARE, DUE
TO PRODUCT RESIDUE/FLAMMABLE VAPOR. DON'T INCINERATE CLOSED
CONTAINERS. EPA HAZARDOUS WA STE NUMBER: D001/F003/F005. UN1263.
FLAMMABLE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:850J CHROMA ONE & CHROMA ONE
Preparer's Name:T R LOUER
CAGE:23027
CAGE:90227
CAGE:23027
============= Composition/Information on Ingredients =============
Ingred Name:FATTY ACIDS, LINSEED OIL, REACTION PRODUCTS POLYMER;
ACRYLIC POLYMER *96-2*
CAS:96591-17-2
Ingred Name:BUTYL ACETATE (N-BUTYL ACETATE) *96-2*
CAS:123-86-4
RTECS #:AF7350000
Other REC Limits:150 PPM
OSHA PEL:710 MG/CUM
ACGIH TLV:713 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:DIKETOPYRROLOPYRROL RED PIGMENT
Ingred Name:AMYL ACETATE
CAS:628-63-7
RTECS #:AJ1925000
Other REC Limits:530 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-2*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 38%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC CONTENT: 4.4 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE NOSE & THROAT
IRRITATION. EXPOSURE TO ISOCYANATES MAY CAUSE RESPIRATORY
SENSITIZATION & MAY CAUSE A DECREASE IN LUNG FUNCTION WHICH MAY BE
PERMANENT. EYES: IRRITATION/BURNING. SK IN: IRRITATION &
DERMATITIS. REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE
PERMANENT BRAIN & CNS DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, EYE WATERING,
HEADACHES, NAUSEA, DIZZINESS, LOSS OF COORDINATION, BURNING,
DISCOMFORT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/PLENTY OF
WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:<100F
Lower Limits:0.8
Upper Limits:23
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:WHEN HEATED > THE FLASH POINT, EMITS
FLAMMABLE VAPORS, WHEN MIXED W/AIR CAN BURN/BE EXPLOSIVE. FINE
MISTS/SPRAYS MAY BE FLAMMABLE AT TEMPS < THE FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:DON'T BREATHE VAPORS. DON'T GET IN EYES/ON
SKIN. WEAR A POSITIVE PRESSURE SUPPLIED AIR VAPOR/PARTICULATE
RESPIRATOR(NIOSH/MSHA TC-19C)& PROTECTIVE MATERIAL. REMOVE SOURCES
OF IGNITION. ABSORB W/INERT MATERIAL. VENTILATE AREA. (SEE SUPP)
Neutralizing Agent:DECONTAMINATION SOLUTIONS: 20% SURFACTANT (TERGITOL
TMN 10), 80% WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
CLOSE CONTAINER AFTER EACH USE. GROUND CONTAINERS WHEN POURING.
DON'T STORE >120F. OBSERVE LABEL PRECAUTIONS.
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/O A
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. DON'T
BREATHE VAPORS. DON'T PERMIT ANYONE W/O PROTECTION IN THE PAINTING
AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A POSITIVE PRESSURE SUPPLIED AIR
RESPIRATOR(NIOSH/MSHAT TC-19C)DURING APPLICATION. INDIVIDUALS W/A
HISTORY OF LUNG/BREATHING PROBLEMS/REACTION TO ISOCYANATES
SHOULDN'T USE/BE EXPOSED TO PRODUCT.
Ventilation:SUFFICIENT IN VOLUME & PATTERN TO KEEP CONTAMINANTS BELOW
APPLICABLE OSHA LIMITS.
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
VOLATILE BY VOLUME: 31.8-86.3%. SPILLS: POUR LIQUID DECONTAMINATION
SOLUTION OVER THE AREA & ALLOW TO SIT 10 MINS, MINIMUM. THIS
PROCEDURE CAN GENERATE PRESSURE. DON'T SEAL CONTAINERS. AFTER 48
HOURS, SEAL CONTAINER & DISPOSE OF MATERIAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:169-415F
Vapor Density:>1
Evaporation Rate & Reference:LESS THAN AIR
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:(SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:HEAT, SPARKS, FLAME, TEMPS >120F.
Hazardous Decomposition Products:CO, CO2, SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE/DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. DON'T INCINERATE IN CLOSED CONTAINERS. FLAMMABLE LIQUID
UN1263.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TETRAPHENYLARSONIUM CHLORIDE HYDROCHLORIDE
Preparer's Name:GIOVANNA F. OLSON
CAGE:4T252
CAGE:91224
CAGE:4T252
============= Composition/Information on Ingredients =============
Ingred Name:TETRAPHENYLARSONIUM CHLORIDE HYDROCHLORIDE (CAT.NO. 1019)
CAS:73003-83-5
Fraction by Wt: 96%+
Other REC Limits:0.5 MG/CUM (AS)
OSHA PEL:0.01 MG/CUM (AS)
ACGIH TLV:0.2 MG/CUM (AS)
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >8%
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K SEE SPP DATA
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ARSENIC COMPOUNDS ARE ACUTELY TOXIC
TARGETING CENTRAL NERVOUS SYSTEM, LIVER, KIDNEYS, AND G/I TRACT.
ALSO SEE CARCINOGENITY.
Explanation of Carcinogenicity:ARSENIC COMPOUNDS ARE CARCINOGENIC WITH
EVIDENCE FROM HUMAN STUDIES.
Effects of Overexposure:NAUSEA,JAUNDICE,ITCHING
Medical Cond Aggravated by Exposure:NONE ARE LISTED
======================= First Aid Measures =======================
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR; IF BRTHNG
DIFF GIVE OXYGEN. EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP&WATER. RMV CONTAM CLTHG&SHOES. INGEST:INDUCE VOMIT. RPT
UNTIL VOMIT IS C LEAR. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:PRODUCES TOXIC FUMES
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP SOLID UP, STORE IN CLOSED CONTAINER FOR
DISPOSAL.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE. KEEP CONTAINERS CLOSED.
MAINTAIN STRICT HYGIENE FOR CHEM HANDLING.
Other Precautions:PROTECT FROM MOISTURE. FOR LAB CHEMICALS, A
DESICCATOR IS RECOMMENDED
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSD TLV,NIOSH/MESA APPR SELF-CNTND BRTHG
APP (POS PR MODE)
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:SAFETY SHOWER & EYE BATH
Work Hygienic Practices:STRICT CHEMICAL HYGIENE PRACTICES
Supplemental Safety and Health
LDLO HUMAN FOR ARSENIC IS 5-15 MG/KG. NOTE THAT MFR LIMIT IS 1984
VINTAGE. PRODUCT IS MFR CAT.NO.1019
================== Physical/Chemical Properties ==================
HCC:T4
Melt/Freeze Pt:M.P/F.P Text:>401F/205C
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE CRYSTALLINE POWDER, N/K ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, ACID FUMES, MOISTURE
Stability Condition to Avoid:HEAT, IGNITION SOURCES
Hazardous Decomposition Products:COMPOUNDS OF ARSENIC AND/OR CHLORINE
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED INCINERATOR OR DISPOSE OF
IN APPROVED CHEMICAL DUMP IN ACCORDANCE WITH LOCAL,STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:230 SEALANT (COLORS ONLY)
CAGE:90300
CAGE:90300
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL, GLYCOL *96-2*
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 1-5%
Other REC Limits:10 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING *96-2*
CAS:1317-65-3
RTECS #:EV9580000
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:ETHYLENE GLYCOL, GLYCOL *96-2*
CAS:107-21-1
RTECS #:KW2975000
Other REC Limits:10 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NONYLPHENOL POLYOXYETHYLENE ETHER; POLYOXYETHYLENE
NONYLPHENOL; TERGITOL NPX; TRITON N-100; NONIONIC SURFACTANT
*96-2*
CAS:9016-45-9
RTECS #:MD0900000
Ingred Name:VOLATILE ORGANIC CONTENT: LESS WATER EXEMPT SOLVENT 15-20
G/L, MATERIAL 10-15 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY IRRITATE EYES, SKIN, NOSE & UPPER
RESPIRATORY SYSTEM. INGESTION: HARMFUL, MAY CAUSE DEPRESSED
RESPIRATION. SKIN: MAY CAUSE IRRITATION. ETHYLENE GLYCOL-INGESTION:
CAN CAUSE GI IRRITATION & DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, VOMITING, DIARRHEA, NAUSEA.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. SKIN: WASH
W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DON'T
INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F
Extinguishing Media:FOAM, WATER, DRY CHEMICALS
Fire Fighting Procedures:USE WATER SPRAY TO COOL EXPOSED SURFACES.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL/SCRAPE UP DRIED
MATERIAL & PLACE INTO CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM CAUSTICS & OXIDIZERS.
KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. KEEP CONTAINERS
FROM EXCESSIVE HEAT & FREEZING.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USAGE & W/ADEQUATE
VENTILATION.
Ventilation:NORMAL ROOM
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:17.5
Vapor Density:<1
Spec Gravity:1.46
Evaporation Rate & Reference:(N-BU AC = 1): <1
Solubility in Water:DISPERSIBLE
Appearance and Odor:COLORED PASTE W/A SLIGHT AMMONIA ODOR
Percent Volatiles by Volume:25-30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS & CAUSTICS.
Stability Condition to Avoid:HEAT, FREEZING
Hazardous Decomposition Products:NORMAL COMBUSTION: CARBON OXIDES,
NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HEEF 25-S
Preparer's Name:SFTY & ENVIRON AFFAIRS
CAGE:DO437
CAGE:DO437
CAGE:27201
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIUM (VI) OXIDE (1:3); (CHROMIC ACID)
CAS:1333-82-0
RTECS #:GB6650000
Fraction by Wt: 20-30%
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.05 MG/M3
Ingred Name:INORGANIC ACID
Fraction by Wt: 60-70%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE: MAY CAUSE SEVERE
BURNS/ULCERATION. SKIN: MAY CAUSE SEVERE BURNS/ULCERATION. CONT
W/HEXAVALENT CHROMIUM CMPDS MAY CAUSE ALLERGIC DERMAT. MAY BE
ABSORB THRU BROKEN SKIN. PERSONS W/CUTS, BRUISES/DER MAT SHOULD
TAKE ADDED PREC TO AVOID SKIN CONT. INHAL: INHAL OF DUST/MIST IS
IRRIT TO MUC MEMB OF UPPER (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CHROMIUM (VI)OXIDE:GROUP 1 (IARC), KNOWN
CARCINOGEN (NTP).
Effects of Overexposure:HLTH HAZ: TRACT. NASAL ITCH & SORENESS,
PERFORATION OF NASAL SEPTUM, DENTAL EROSION & CHRONIC ASHTMATIC
BRONCHITIS MAY RESULT FROM RPTD EXPOS. (CHRONIC) LONG TERM EXPOS
CAN CAUSE LIVER & KIDNEY DMG.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IN CASE OF CONT, IMMED FLUSH W/FLOWING WATER FOR AT
LEAST 15 MIN. GET MD. SKIN: FLUSH EXPSD AREA W/WATER REMOVING
CONTAM CLTHG. WASH AREA THORO W/SOAP & WATER. SEE MD. INHAL: MOVE
EXPSD INDIV TO FRESH AIR. GIVE OXYGEN/ARTF RESP IF NEEDED. INGEST:
NEVER GIVE FLUIDS/INDUCE VOMITING IF PATIENT IS UNCON/HAVING
CONVULSIONS. SEE MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY AND CO*2. A CORROSIVE LIQUID IS FORMED
IF WATER IS USED.
Fire Fighting Procedures:AVOID SKIN AND EYE CONTACT. WEAR NIOSH/MSHA
APPROVED SCBA & FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DO NOT INHALE DUST.IRRIT FUMES/MIST MAY
DEVELOP IF EXPSD TO ELEVATED TEMP/OPEN FLAME.CORR,STRONG
OXIDANT-CONT W/ORG MATL MAY CAUSE FIRE/VIGOROUS RXN.
================== Accidental Release Measures ==================
Spill Release Procedures:MAY BE HAZ TO AQUATIC LIFE IF RELS TO OPEN
WATERS. IN CASE OF SPILL, CAREFULLY SWEEP UP MATL & PLACE IN A
SUITABLE CNTNR (LINED STEEL DRUM) FOR DISP. AVOID CREATING A DUSTY
ATMOSPHERE. AFTER SWEEPING, FLUSH AREA WHERE SPILL OCCURRED WITH
(SUPP DATA)
Neutralizing Agent:SEE SPILL/RELEASE PROCEDURES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN AREA SUITABLE FOR STRONG
OXIDIZERS. KEEP CNTNRS CLSD. DO NOT GET IN EYES, ON SKIN, OR CLTHG.
DO NOT BREATHE DUST/MIST FROM SOLUTIONS.
Other Precautions:EMPTY CNTNRS MAY RETAIN HAZ RESIDUE. HANDLE AS IF
FULL, OBSERVING ALL PREC. DO NOT WEAR CONTACT LENSES. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED AIR-SUPPLIED OR
HIGH-EFFICIENCY CHEMICAL CARTRIDGE RESPIRATOR.
Ventilation:LOCAL EXHAUST IS RECOMMENDED. MECHANICAL (GENERAL) IS
REQUIRED.
Other Protective Equipment:PROTECTIVE CLTHG. AN EYEWASH & EMERGENCY
SHOWER SHOULD BE READILY AVAIL. USE FRESH CLTHG DAILY.
Work Hygienic Practices:TAKE HOT SHOWER AFTER WORK USING PLENTY OF
SOAP.
Supplemental Safety and Health
SPILL PROC: WATER. NEUTRALIZE AREA OF SPILL WITH SODA ASH. CONTAIN
WATER RESIDUE MIXTURE FOR DISPOSAL.
================== Physical/Chemical Properties ==================
HCC:C1
Solubility in Water:COMPLETE
Appearance and Odor:YELLOWISH BROWN SOLID.
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, REDUCERS, ORGANIC MATERIALS, ACETIC ACID AND ALCOHOL.
Stability Condition to Avoid:KEEP CNTNR TIGHTLY CLSD.GRANULES WILL PICK
UP MOISTURE FROM AIR.MAY EXPLODE ON CONT W/REDUCERS;IGNITES ON CONT
W/ORG.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:REDUCE HEXAVALENT CHROME TO TRIVALENT FORM.
COLLECT SOLIDS & DISPOSE OF AS SOLID WASTE. FOLLOW ALL CHEM
POLLUTION CONTROL REGS. DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL REGULATION S .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ACRYLIC ENAMEL 80-149
Preparer's Name:THOMAS E MAREK
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-(2-ETHOXYETHOXY)-; (DIETHYLENE GLYCOL MONOETHYL
ETHER) VP: 0.10
CAS:111-90-0
RTECS #:KK8750000
Fraction by Wt: 4-8%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT WITH SKIN MAY CAUSE IRRITATION
OR RASH. EYES: MAY CAUSE SLIGHT IRRITATION OR REDNESS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:EYES: REDNESS. INGESTION: NAUSEA.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . INGEST: INDUCE VOMITING AND CALL A PHYSICIAN AT ONCE. EYES:
FLUSH WITH WATER FOR AT LEAST 15 MINUTES AND CALL A PHYSICIAN. SK
IN: WASH AFFECTED AREAS WITH SOAP AND WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE AT BOILING
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP WITH WATER BEFORE ALLOWING TO DRY.
SODIUM CHLORIDE OR CALCIUM CHLORIDE MAY BE SPRINKLED ON THE SPILL;
THIS MAY COAGULATE THE LATEX AND FACILITATE CLEANING WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED OR REPEATED INHALATION
OF SPRAY MISTS. USE WITH ADEQUATE VENTILATION.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SHOULD PREVENT INHALATION OF SPRAY MIST OR
HEATED VAPORS. NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:LOCAL EXHAUST AND GENERAL VENTILATION RECOMMENDED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . AS REQUIRED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV: 1.05-1.25 (H*2O = 1)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:SUPDAT
Evaporation Rate & Reference:<0.01 (ETHER=1)
Solubility in Water:INFINITE
Appearance and Odor:WHITE OR COLORED OPAQUE LIQUID, SLIGHTLY SWEET
ODOR.
Percent Volatiles by Volume:64-69
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:AFTER WATER HAS EVAPORATED, POLYMERIC
BINDER CAN BURN TO PRODUCE CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF IN SANITARY LANDFILL IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-WHITE FIRERETARDANT COATING, 5 GAL
CAGE:41817
CAGE:41817
============= Composition/Information on Ingredients =============
Ingred Name:VARNISH; (CLEAR VARNISH)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:UREA; (BASIC UREA COCONDENSATE) (DISSOLVED IN INGREDIENT 3)
CAS:57-13-6
RTECS #:YR6250000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 29%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:IRRITATION OF THE
RESPIRATORY TRACT AND ACUTE CENTRAL NERVOUS SYSTEM DEPRESSION
CHARACTERIZED BY HEADACHE AND DIZZINESS. EYE CONTACT:IRRITATION.
SKIN CONTACT:IRRITATION. INGESTION:CALL PHYS ICIAN IMMEDIATELY.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE FROM EXPOSURE. RESTORE BREATHING. CALL A
PHYSICIAN. EYE CONTACT:RINSE IMMEDIATELY WITH PLENTY OF WATER FOR
AT LEAST 15 MINUTES. SKIN:REMOVE CONTAMINATED CLOTHING. WASH
AFFECTED AREAS WITH PLENTY OF WATER AND SOAP. INGESTION:DO NOT
INDUCE VOMITING. KEEP WARM AND QUIET. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:SUITABLE:WATER.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:AFTER SOILAGE, LEAKAGE, GAS LEAKAGE:REMOVE
WITH INERT ABSORBENT. ECOLOGICAL EFFECTS:DO NOT EMPTY INTO DRAINS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED IN A
WELL VENTILATED PLACE. OPEN AND HANDLE CONTAINERS WITH CARE.
Other Precautions:PROTECT FROM FROST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAYING USE NIOSH APPROVED RESPIRATORY
EQUIPMENT.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:WHEN USING DO NOT EAT, DRINK OR SMOKE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.33
pH:4.5-5
Solubility in Water:MISCIBLE
Appearance and Odor:WHITISH LIQUID; TYPICAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE, WHEN STORED PROPERLY.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. (INCINERATION OR CONTROLLED LANDFILL).
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TRANS-1,4-DICHLORO-2-BUTENE, O-658
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTENE, 1,4-DICHLORO-, (E)-;
(TRANS-1,4-DICHLORO-2-BUTENE) (SARA 302)
CAS:110-57-6
RTECS #:EM4903000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT): 150 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAN BE FATAL IF ABSORBED
THROUGH THE SKIN, INHALED, OR SWALLOWED. CAN CAUSE DELAYED HEALTH
EFFECTS. LACHRYMATOR. CAUSES SEVERE EYE IRRITATION. CAN CAUSE SKIN
IRRITATION. DUST AND/OR VAPORS CANCAUSE IRRITATION TO RESPIRATORY
TRACT. INGESTION MAY CAUSE SEVERE CORROSION OF THE GASTROINTESTINAL
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: TRACT. CHRONIC: CHRONIC EXPOSURE MAY
CAUSE BRONCHITIS. PROLONGED EXPOSURE MAY CAUSE NAUSEA, HEADACHE,
DIZZINESS AND/OR EYE DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:AN ANTIDOTE IS A SUBSTANCE INTENDED TO COUNTERACT EFT OF
POIS. IT SHOULD BE ADMIN ONLY BY MD/TRAINED EMER PERS. MED ADVICE
CAN BE OBTAINED FROM POIS CTL CTR. EYES: FLUSH CONTINUOUSLY W/WATER
FOR AT LE AST 15 MIN. SKIN: FLUSH W/WATER FOR 15-20 MIN. IF NO
BURNS HAVE OCCURRED, USE SOAP & WATER TO CLEANSE SKIN. INHAL:
REMOVE TO FRESH AIR. ADMIN OXYGEN IF DFCLT BRTHG. IF BRTHG HAS
STOPPED, (SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point:127F,53C
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL POWDER OR WATER
SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE OSHA-REGULATED
EQUIPMENT. VENTILATE AREA. ABSORB ON VERMICULITE OR SIMILAR
MATERIAL. SWEEP UP AND PLACE IN AN APPROPRIATE CONTAINER. HOLD FOR
DISPOSAL. WASH CONTAMINATE D SURFACES TO REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:ALL CHEMICALS SHOULD BE CONSIDERED
HAZARDOUS. AVOID DIRECT PHYSICAL CONTACT! USE APPROPRIATE OSHA/MSMA
APPROVED SAFETY EQUIPMENT.
Other Precautions:AVOID CONT W/SKIN, EYES, & CLTHG. KEEP TIGHTLY CLSD &
STORE IN COOL DRY PLACE. STORE ONLY W/COMPATIBLE CHEM. PERS NOT
SPECIFICALLY & PROPERLY TRAINED SHOULD NOT HANDLE THIS CHEM/ITS
CONTR. THIS PROD I S FURNISHED FOR LAB USE ONLY! (SUP DAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN IN THE
LABORATORY.
Supplemental Safety and Health
FIRST AID PROC:ADMIN ARTF RESP. IF PATIENT IN CARD ARREST, ADMIN CPR.
CONTINUE LIFE SUPPORTING MEASURES UNTIL MED ASSIST HAS ARRIVED.
INGEST:CALL MD IMMED. OTHER PREC:PROD MAY NOT BE USED AS DRU GS,
COSMETICS, AGRICULTURAL/PESTICIDAL PRODS, FOOD ADDITIVES/HOUSEHOLD
CHEM. EYE PROT: FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:329F,165C
Melt/Freeze Pt:M.P/F.P Text:37.4F,3.0C
Spec Gravity:1.183
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS, STRONG BASES.
Stability Condition to Avoid:COMBUSTIBLE. SENSITIVE TO LIGHT. DARK
COLOR DOES NOT AFFECT PURITY. DECOMPOSED BY MOISTURE.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
DECOMPOSITION PRODUCTS ARE CORROSIVE. DECOMPOSITION PRODUCTS ARE
FLAMMABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:180 5563 EKTAPRINT 2 DEVELOPER REPLENISHER,
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70 - 75%
Other REC Limits:NONE SPECIFIED
Ingred Name:HYDROXYLAMINE SULFATE
CAS:10039-54-0
RTECS #:NC5425000
Fraction by Wt: 15 - 20%
Other REC Limits:NONE SPECIFIED
Ingred Name:LITHIUM CHLORIDE
CAS:7447-41-8
RTECS #:OJ5950000
Fraction by Wt: 5 - 10%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-INHALATION:LOW
HAZARD.EYES/SKIN:CAUSES IRRITATION.MAY CAUSE AN ALLERGIC SKIN
REACTION.INGESTION:HARMFUL.CHRONIC-NOT GIVEN.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO INGREDIENT
LISTED AS CARCINOGEN BY IARC,NTP, OR OSHA.
Effects of Overexposure:SEE HEALTH HAZARDS SECTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION.EYE/SKIN:IMMEDIATELY FLUSH WITH WATER
FOR AT LEAST 15 MINUTES.INHALATION:REMOVE TO FRESH
AIR.INGESTION:INDUCE VOMITING IMMEDIATELY AS DIRECTED BY MEDICAL
PERSONNEL.CALL A PHYSICI AN OR POISON CONTROL CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES. KEEP
PERSONNEL REMOVED.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT
DURING CLEAN UP.FLUSH SPILLS TO SEWER WITH LARGE AMOUNT OF WATER.
Neutralizing Agent:NOT GIVEN
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-KEEP FROM CONTACT WITH
OXIDIZING MATERIALS.
Other Precautions:AVOID BREATHING VAPORS OR MIST. AVOID CONTACT WITH
EYES,SKIN,OR CLOTHING. WASH THOROUGHLY AFTER HANDLING.USE
VENTILATION THAT IS ADEQUATE TO KEEP EMPLOYEE EXPOSURE TO AIRBORNE
CONCENTRATIONS BELOW REC OMMENDED EXPOSURE LIMITS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORS ARE NOT NEEDED FOR NORMAL USE.A
NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR WITH AN ORGANIC VAPOR
CARTRIDGE OR A POSITIVE PRESSURE AIR SUPPLIED RESPIRATOR WHERE
AIRBORNE CONCENTRATIONS > TLV.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER.IMPERVIOUS
CLOTHING SUCH AS BOOTS,APRON,WHOLE BODY SUIT MADE FROM NEOPRENE.
Work Hygienic Practices:USE OF A NON-ALKALINE TYPE OF SKIN CLEANSER AND
REACTION.
Supplemental Safety and Health
PART B OF A 4 PART PRODUCT.
================== Physical/Chemical Properties ==================
HCC:C3
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.17
pH:2.7
Evaporation Rate & Reference:4.0 (N-BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,COLORLESS LIQUID
Percent Volatiles by Volume:73
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES AND FLAMES
Hazardous Decomposition Products:MAY PRODUCE NITROGEN AND HYDROGEN
CHLORIDE GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE, OR LOCAL LAWS. THIS CHEMICAL FORMULATION IS A
STRONGLY ACIDIC AQUEOUS SOLUTION, AND THIS PROPERTY MAY CAUSE
ADVERSE ENVIRONMENTAL EF FECTS IF DISCHARGED TO THE ENVIRONMENT
UNTREATED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1031101 ELECKTRA
CAGE:FO503
CAGE:94746
CAGE:FO503
============= Composition/Information on Ingredients =============
Ingred Name:SILVER (SARA III)
CAS:7440-22-4
RTECS #:VW3500000
Fraction by Wt: 58.50%
Other REC Limits:10 UG/CUM
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:INDIUM
CAS:7440-74-6
RTECS #:NL1050000
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3; 9192
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 14.50%
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Medical Cond Aggravated by Exposure:WILSON'S DISEASE (COPPER)
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR, OXYGEN OR ART. RESPIRATION IF
NEEDED. INGESTION: DILUTE W/WATER, SEEK MEDICAL ATTENTION. EYES:
FLUSH W/WATER FOR 20 MINUTES, SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP/VACUUM SOLIDS, DON'T RAISE DUST.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CREATING FUMES OR DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHILE GRINDING
Ventilation:USE LOCAL EXHAUST VENTILATION
Other Protective Equipment:APRONS
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1590-1810F
Spec Gravity:10.4
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE-LIGHT GOLD
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:SALVAGE/REUSE DISPOSE ACCORDING TO LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TEFLON FLUOROCARBON RESIN PTFE GRANULAR (SU
Preparer's Name:W. H. MARTIN
CAGE:0ERJ7
CAGE:0ERJ7
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE,TETRAFLUORO-,POLYMER; (POLYTETRAFLUOROETHYLENE)
CAS:116-14-3
RTECS #:KX4025000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGESTION/SKIN: NOT TOXIC. EYE:
MECHANICAL IRRITATION. INHALATION: WHEN THERMALLY DECOMPOSED BY
HEATING ABOVE 325C, OR BY SMOKING TOBACCO OR CIGARETTES
CONTAMINATED WITH POLYMER DUST, MAY CAUSE POLYMER FUME FEVER.
SYMPTOMS ARE FLU LIKE, WITH CHILLS AND FEVER, WHICH MAY NOT OCCUR
UNTIL SEVERAL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HEALTH HAZARDS: HOURS AFTER EXPOSURE AND PASS
OFF WITHIN 36-48 HOURS, EVEN IN ABSENCE OF TREATMENT. DU PONT
RECOMMENDS TREATING POLYMER DUST AS NUISANCE PARTICULATE, AND HAS
ESTABLISHED A PEL OF 10 MG /M3 TOTAL DUST, SAME AS TLV FOR OTHER
NUISANCE PARTICULATES. CHRONIC: NONE KNOWN.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. CONSULT PHYSICIAN IF SYMPTOMS
PERSIST. EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
CONSULT PHYSICIAN IF SYMPTOMS PERSIST. SKIN: COOL RAPIDLY WITH COLD
WATE R. DO NOT ATTEMPT TO PEEL POLYMER FROM SKIN. OBTAIN MEDICAL
ATTENTION FOR THERMAL BURN. INGESTION: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:DOES NOT FLASH
Extinguishing Media:WATER, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . DOES NOT BURN WITHOUT AN EXTERNAL FLAME.
Unusual Fire/Explosion Hazard:TOXIC FLUORINE COMPOUNDS EVOLVED IN FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP TO AVOID SLIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTAMINATION. KEEP CONTAINERS
CLOSED.
Other Precautions:AVOID CONTAMINATION OF CIGARETTES OR TOBACCO WITH
POLYMER DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WHEN
TEMPERATURE EXCEEDS 325C IF VENTILATION IS INADEQUATE TO MAINTAIN
HF CONCENTRATION BELOW PERMISSIBLE EXPOSURE LIMIT.
Ventilation:USE LOCAL EXHAUST TO COMPLETELY REMOVE VAPORS AND FUMES
LIBERATED DURING HOT PROCESSING FROM WORK AREA.
Other Protective Equipment:LONG SLEEVE SHIRT IS RECOMMENDED.
Work Hygienic Practices:AVOID CONTAMINATION OF CIGARETTES OR TOBACCO
WITH POLYMER DUST.
Supplemental Safety and Health
TRADE NAME/PART #: RESIN, TE6368. HAZARDOUS DECOMPOSITION PRODUCTS:
PERMISSIBLE EXPOSURE LIMIT FOR HF IS 3 PPM. PARTICULATE MATTER
EVOLVED FROM OVERHEATING MAY CAUSE POLYMER FUME FEVER. TOXIC
FLUORINE COMPOUNDS EVOLVED IN FIRE.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:648F,342C
Spec Gravity:2.1-2.3
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE GRANULES, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MOLTEN ALKALI METALS, INTERHALOGEN COMPOUNDS.
Stability Condition to Avoid:ATMOSPHERE OF 95% OXYGEN WHEN AN IGNITION
SOURCE IS PRESENT.
Hazardous Decomposition Products:>325C TEFLON PTFE GRANULAR RESINS CAN
EVOLVE TOX GASEOUS MATLS SUCH AS HYDROGEN FLUORIDE &
PERFLUOROOLEFINS.OSHA(SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL PREFERRED; DISPOSAL METHODS MUST
CONFORM TO FEDERAL, STATE, AND LOCAL REGULATIONS. WITH
INCINERATION, ACIDIC GASEOUS PRODUCT MUST BE REMOVED BY ALKALINE
SCRUBBING.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:05902 RHODAMINE 590 TETRAFLUOROBORATE
Preparer's Name:LARRY KNAAK
CAGE:9Z504
CAGE:9Z504
============= Composition/Information on Ingredients =============
Ingred Name:RHODAMINE 590 TETRAFLUOROBORATE
CAS:54854-14-7
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: LOW HAZARD FOR USUAL
INDUSTRIAL HANDLING. SKIN: LOW HAZARD FOR USUAL INDUSTRIAL
HANDLING. EYES: NO SPECIFIC HAZARD KNOWN. CONTACT MAY CAUSE
TRANSIENT IRRITATION. INGESTION: EXPECTED TO BE A LOW INGESTION
HAZARD.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION/SKIN: LOW HAZARD FOR USUAL
INDUSTRIAL HANDLING. EYES: NO SPECIFIC HAZARD KNOWN. CONTACT MAY
CAUSE TRANSIENT IRRITATION. INGESTION: EXPECTED TO BE A LOW
INGESTION HAZARD.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH AFTER EACH
CONTACT. EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15 MINS.
INGESTION: DRINK 1-2 GLASSES OF WATER. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING
Unusual Fire/Explosion Hazard:FIRE/EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP MATERIAL & PACKAGE FOR SAFE FEED TO
AN INCINERATOR.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CONTACT W/OXIDIZING
MATERIALS. AVOID UNNECESSARY PERSONAL CONTACT. AVOID CONTACT W/EYES
& PROLONGED/REPEATED SKIN CONTACT.
Other Precautions:AVOID CONTINUOUS/REPETITIVE BREATHING OF DUST. USE
ONLY WITH ADEQUATE VENTILATION. LABORATORY USE ONLY BY TECHNICALLY
QUALIFIED INDIVIDUAL. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE
& DURING TRANS PORT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH APPROVED DUST RESPIRATOR.
Ventilation:GOOD GENERAL ROOM. LOCAL EXHAUST IF NEEDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:482-491F
Vapor Pres:0
Solubility in Water:SLIGHT
Appearance and Odor:RED CRYSTALS W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:FIRE/EXCESSIVE HEAT
Hazardous Decomposition Products:CO2, CO, HYDROGEN FLUORIDE GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE BY INCINERATION/CONTRACT W/LICENSED
CHEMICAL WASTE DISPOSAL AGENCY IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: 845 1817,KODAK IMAGESOURCE M51CP TONER
Cage: 19139
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 0ZW37
Cage: 19139
Cage: TO857
Country: JA
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NOT PROVIDED
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EFFECTS OF EXPOSURE: INHALATION: EXPECTED TO BE A LOW
HAZARD FOR RECOMMENDED HANDLING. EYES: EXPECTED TO BE A LOW HAZARD FOR
RECOMMENDED HANDLING. MAY CAUSE TRANSIENT IRRITATION. SKIN: EXPECTED TO BE A
LOW HAZARD FOR RECOMMENDED HANDLING. INGESTION: EXPECTED TO BE A LOW
INGESTION HAZARD. OVEREXPOSURE TO CARBON BLACK DUST MAY RESULT IN IRRITATION
OF THE RESPIRATORY TRACT AND BENIGN DEPOSITION OF CA RBON BLACK IN THE LUNG.
Explanation Of Carcinogenicity: - CARCINOGENICITY CLASSIFICATION (COMPONENTS
PRESENT AT 0.1% OR MORE): - INTERNATIONAL AGENCY FOR RESEARCH ON CANCER
(IARC) (CARBON BLACK): 2B - AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL
HYGIENIS TS (ACGIH): NONE - NATIONAL TOXICOLOGY PROGRAM (NTP): NONE -
OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION (OSHA): NONE
Signs And Symptions Of Overexposure: EYES: MAY CAUSE TRANSIENT IRRITATION.
OVEREXPOSURE TO CARBON BLACK DUST MAY RESULT IN IRRITATION OF THE RESPIRATORY
TRACT AND BENIGN DEPOSITION OF CARBON BLACK IN THE LUNG.
Medical Cond Aggravated By Exposure: NOT PROVIDED
First Aid: INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL ATTENTION
IF SYMPTOMS PERSIST. EYES: ANY MATERIAL THAT CONTACTS THE EYE SHOULD BE
WASHED OUT IMMEDIATELY WITH WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
SKIN: WASH WITH SOAP AND WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: DO NOT USE A VACUUM CLEANER TO CLEAN UP SPILLS OF
POWDERED TONERS. THE VERY FINE PARTICLES CAN CAUSE A FIRE OR EXPLOSION. SWEEP
MATERIAL ONTO PAPER AND PLACE IN A FIBER CARTON. AVOID GENERATION OF DUS T.
Neutralizing Agent: NOT RELEVANT
Waste Disposal Methods: DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT TO
NATIONAL, STATE, OR LOCAL LAWS. INCINERATE.
Handling And Storage Precautions: KEEP CONTAINER CLOSED. POWDERED MATERIAL MAY
FORM EXPLOSIVE DUST-AIR MIXTURES. MINIMIZE DUST GENERATION AND ACCUMULATION.
KEEP AWAY FROM SOURCES OF IGNITION. KEEP FROM CONTACT WITH OXIDIZING
MATERIALS .
Other Precautions: AVOID BREATHIG DUST. AVOID CONTACT WITH EYES, SKIN, AND
CLOTHING. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Extinguishing Media: WATER SPRAY, CARBON DIOXIDE (CO2), DRY CHEMICAL
Fire Fighting Procedures: FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS. WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard: POWDERED MATERIAL MAY FORM EXPLOSIVE DUST-AIR
MIXTURES.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS, AN APPROVED RESPIRATOR MUST
BE WORN. RESPIRATOR TYPE: DUST. IF RESPIRATORS ARE USED, A PROGRAM SHOULD BE
INSTITUTED TO ASSURE COMPLIANCE WITH OSHA STANDARD 29CFR 1910.134 AND 29CFR
1910.1048.
Ventilation: GOOD VENTILATION (TYPICALLY 4-6 ROOM VOLUMES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS.
SHOULD BE WORN.
Other Protective Equipment: EYE BATH, WASHING FACILITIES, SAFETY SHOWER.
Work Hygienic Practices: IT IS A GOOD INDUSTRIAL HYGIENE PRACTICE TO MINIMIZE
EYE CONTACT. IT IS A GOOD INDUSTRIAL HYGIENE PRACTICE TO MINIMIZE SKIN
CONTACT.
Supplemental Safety and Health: USE PROCESS ENCLOSURES, LOCAL EXHAUST
VENTILATIN, OR OTHER ENGINEERING CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW
RECOMMENDED EXPOSURE LIMITS.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
NRC/State LIC No: NOT RELEVANT
Melt/Freeze Pt: =122.2C, 252.F
Decomp Text: NOT PROVIDED
Vapor Pres: NEGLIGIBLE
Vapor Density: NEGLIGIBLE
Spec Gravity: 1.3
Evaporation Rate & Reference: NOT PROVIDED
Solubility in Water: NEGLIGIBLE
Appearance and Odor: BLACK ODORLESS SOLID (POWDER)
Percent Volatiles by Volume: NEGLIGIBLE
Corrosion Rate: NOT PROVIDED
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: MATERIALS CONTAINING SIMILAR STRUCTURAL GROUPS
ARE NORMALLY STABLE.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE, OXIDES OF
NITROGEN, OXIDES OF SULFUR
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE
=======================================================
Toxicological Information
=======================================================
Toxicological Information: EFFECTS OF EXPOSURE: INHALATION: EXPECTED TO BE A
LOW HAZARD FOR RECOMMENDED HANDLING. EYES: EXPECTED TO BE A LOW HAZARD FOR
RECOMMENDED HANDLING. MAY CAUSE TRANSIENT IRRITATION. SKIN: EXPECTED TO BE A
LOW HAZARD FOR RECOMMENDED HANDLING. INGESTION: EXPECTED TO BE A LOW
INGESTION HAZARD. OVEREXPOSURE TO CARBON BLACK DUST MAY RESULT IN IRRITATION
OF THE RESPIRATORY TRACT AND BENIGN DEPOSITION OF CA RBON BLACK IN THE LUNG.
=======================================================
Ecological Information
=======================================================
Ecological: THIS MATERIAL HAS NOT BEEN TESTED FOR ENVIRONMENTAL EFFECTS. IN A
SPILL SITUATION THIS MATERIAL MAY BE VISUALLY UNPLEASANT; HOWEVER, IT IS NOT
EXPECTED TO CAUSE ADVERSE ENVIRONMENTAL EFFECTS.
=======================================================
=======================================================
Transport Information: FOR TRANSPORTATION INFORMATION REGARDING THIS PRODUCT
CALL THE KODAK WORLDWIDE TRANSPORTATION HAZMAT HOT LINE: (800) 255-3434
BETWEEN 8 A.M. AND 5 P.M. (EASTERN STANDARD TIME), MONDAY THROUGH FRIDAY.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: CHEMICAL(S) SUBJECT TO THE REPORTING REQUIREMENTS
OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION
ACT (SARA) OF 1986 AND 40 CFR PART 372: NONE.
Federal Regulatory Information: NOT PROVIDED
State Regulatory Information: MATERIAL(S) KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER: NONE. MATERIAL(S) KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
ADVERSE REPRODUCTIVE EFFECTS: NONE.
=======================================================
Other Information
=======================================================
Other Information: LOW HAZARD FOR RECOMMENDED HANDLING.
=======================================================
Transportation Information
=======================================================
Trans ID NO: 154158
Product ID: 845 1817,KODAK IMAGESOURCE M51CP TONER
Review Date: 07/22/2000
Net Unit Weight: 1.76 LBS
Multiple KIT Number: 0
Unit Of Issue: CY
Type Of Container: CYLINDER
Additional Data: THE WEIGHT IS 800 GRAMS, PER MSDS.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: 845 1817,KODAK IMAGESOURCE M51CP TONER
Cage: 19139
Company Name: EASTMAN KODAK CO GOVERNMENT MARKETS CONTRACTS
Street: 343 STATE ST
Zipcode: 14650-1115
Label Required IND: Y
Date Of Label Review: 07/22/2000
Status Code: A
MFG Label NO: NOT PROVIDED
Label Date: 09/23/1998
Origination
Skin Protection IND: NO
Signal Word: CAUTION
Respiratory Protection IND: NO
Health Hazard: None
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: TARGET ORGANS: NOT PROVIDED. LOW HAZARD FOR RECOMMENDED
HANDLING. AVOID BREATHING DUST. AVOID CONTACT WITH EYES, SKIN, AND CLOTHING.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING. FIRS T AID:
TREAT SYMPTOMATICALLY. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. KEEP OUT OF
REACH OF CHILDREN. FOR ADDITIONAL INFORMATION, SEE MATERIAL SAFETY DATA SHEET
(MSDS) FOR THIS MATERIAL.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WATER, REAGENT
CAGE:TO375
Contract Num:SP0450-99-D-4040
CAGE:0P668
CAGE:TO375
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT GIVEN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO ACUTE OR CHRONIC HEALTH HAZARDS.
HOWEVER DEIONIZED WATER IS NOT RECOMMENDED FOR DRINKING WATER.
Effects of Overexposure:NOT APPLICABLE.
Medical Cond Aggravated by Exposure:NOT APPLICABLE.
======================= First Aid Measures =======================
First Aid:NOT APPLICABLE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:NONE. NONFLAMMABLE MATERIAL.
Fire Fighting Procedures:NONE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID SLIPPING HAZARD CAUSED BY SPILLED
MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT FREEZE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:=100.C, 212.F
Spec Gravity:1
Solubility in Water:100%
Appearance and Odor:CLEAR ODERLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN DRAIN OR SEWER SYSTEM. HOWEVER, USED
WATER MUST BE DISPOSED OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:REGENCY INT 100% ACRYLIC SEMI-GLOSS ENAMEL, W2290
CAGE:FO133
CAGE:97903
CAGE:FO133
============= Composition/Information on Ingredients =============
Ingred Name:WATER. VAP DENS:LTR/AIR.
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 45%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC RESIN; (100% ACRYLIC RESIN). VAP DENS:HVR/AIR.
Fraction by Wt: 25%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE). VAP DENS:HVR/AIR.
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 25%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL). VP:0.22 @ 69F. VAP
DENS:HVR/AIR. LEL:2.5%.
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER W/2,2,4-TRIMETHYL-1,
3-PENTANEDIOL; (2,2,4 TRIMETHYLPENTANEDIOL-1, 3 (ING 6)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 5:MONOISOBUTYRATE). VP:1 @ 188F. VAP DENS:HVR/AIR.
LEL:0.62%.
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CASTOR OIL; (CASTOR OIL, ETHOXYLATED) (MFR'S CAS
NO:61791-12-6). VAP DENS:HVR/AIR.
CAS:8001-79-4
RTECS #:FI4100000
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BICYCLIC OXAZOLIDINES SOLUTION (HEMIACETALS); (NUOSEPT95).
VAP DENS:HVR/AIR.
CAS:56709-13-8
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUNDS (LESS WATER): 136.2 G/L.
RTECS #:9999999VO
Ingred Name:SUPDAT:COMBINATION OF PARTICULATES & VAP. WHEN USED IN
CONFINED AREAS, WEAR NIOSH/MSHA APPRVD AIR SUPPLY RESPS/ (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:HOODS. USE NIOSH/MSHA APPRVD RESPS WHEN FLAME
CUTTING, WELDING, BRAZING & SANDING MATL COATED W/THIS (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:PRODUCT. FOLLOW RESPIRATOR MFR'S DIRECTIONS FOR
RESPIRATOR USE.
RTECS #:9999999ZZ
Ingred Name:VENT:STDS IN MIXING, APPLICATION & CURING AREAS & TO REMOVE
SANDING DUSTS OF DRIED COATING & DECOMP PROD DURING (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:WELDING & FLAME CUTTING ON SURFACES COATED W/THIS
PRODUCT.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRITATION OF RESPIRATORY
TRACT; HEADACHE, NAUSEA, DIZZINESS. EYE/SKIN CONTACT:MAY CAUSE
IRRITATION. INGEST:NO EFFECTS ANTICIPATED FROM INGESTION INCIDENTAL
TO NORMAL USE. LARGER QUANTITIE S MAY CAUSE DISTRESS OF THE
DIGESTIVE TRACT & NAUSEA. CHRONIC:PROLONGED & REPEATED BREATHING OF
SPRAY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:MIST &/OR SANDING DUST OVER A PERIOD
OF YEARS MAY CAUSE DUST DISEASE OF THE LUNGS.
Medical Cond Aggravated by Exposure:NONE WHEN USED I/A/W SAFE HANDLING
& USE INFORMATION.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. EYES:FLUSH W/LARGE AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES. GET MEDICAL ASSISTANCE. SKIN:REMOVE
W/SOAP & WATER. REMOVE SOILED CLOTHING. INGEST:DRINK 1-2 GLASSES OF
WATER TO DILUTE. DO NOT INDUCE VOMITING. CONSULT MD IMMEDIATELY.
TREAT SYMPTOMATICALLY. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:NONE
Lower Limits:SEE INGS
Extinguishing Media:IN CASE OF FIRE, USE CO*2, DRY CHEMICAL, FOAM OR
OTHER NFPA APPROVED METHOD FOR TREATING A CLASS B FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
SUMMON PROFESSIONAL FIREFIGHTERS. WATER SPRAY MAY BE INEFT. IF
WATER IS USED, FOG NOZZ ARE PREF. IF(SUPDAT)
Unusual Fire/Explosion Hazard:DUE TO PRESS BUILD-UP, CLSD CNTNRS EXPOS
TO EXTREME HEAT MAY EXPLODE. AFTER WATER EVAPS, REMAINING MATL WILL
BURN. DURING EMER CNDTNS, OVEREXP TO DECOMP(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:WASH W/WATER. BEFORE ATTEMPTING CLEAN-UP,
REFER TO HAZARD CAUTION INFORMATION IN OTHER SECTIONS OF THIS MSDS.
CONTAIN SPILLED MATERIAL & REMOVE W/INERT ABSORBENT. STORE IN
CLOSED CONTAINERS UNTIL PROP ERLY DISPOSED OF.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <110F & KEEP FROM FREEZING. KEEP
CONTAINER CLOSED WHEN NOT IN USE. DO NOT REUSE EMPTY CONTAINERS.
KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DO NOT BREATHE VAPORS, SPRAY MIST OR SANDING DUST.
USE ONLY W/ADEQUATE VENTILATION. DO NOT GET IN EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAY APPLIED IN OUTDOOR/OPEN AREAS
W/UNRESTRICTED VENT & DURING SANDING/GRINDING OPERATIONS, USE
NIOSH/MSHA APPRVD MECH FILTER RESP TO REMOVE SOLID AIRBORNE
PARTICLES OF OVERSPRAY & SANDING DUST . WHEN USED IN RESTRICTED
AREAS,(SUPDAT)
Ventilation:PROVIDE GEN DILUTION/LOC EXHST VENT IN VOL & PATTERN TO
KEEP AIR CONTAM CONC BELOW CURRENT APPLIC SFTY & HLTH (ING 13)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:REMOVE & WASH SOILED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING, SMOKING OR USING WASHROOM.
Supplemental Safety and Health
FIRE FIGHT PROC:EXPOS TO FIRE/EXTREME HEAT, WATER SHOULD BE USED TO
COOL CLSD CNTNRS & PVNT PRESS BUILD-UP/POSS AUTO-IGNIT. EXPLO
HAZ:PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT.
OBTAIN MED ATTN. HAZ DECOMP PROD:LISTED IN INGS. RESP PROT:WEAR
NIOSH/MSHA APPRVD CHEM/MECH FILTERS DESIGNED TO REMOVE (ING 10)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGS
Vapor Density:SEE INGS
Spec Gravity:1.31
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:68.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/MATERIALS THAT ARE INCOMPATIBLE W/WATER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY CAUSE HAZ FUMES WHEN HEATED TO
DECOMP. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE & OXIDES
OF METALS (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SAFE & SIMPLE WOOD STAIN, BLACK WALNUT
CAGE:GO179
CAGE:GO179
============= Composition/Information on Ingredients =============
Ingred Name:DIPROPYLENE GLYCOL, MONOMETHYL ETHER; (DIPROPYLENE GLYCOL
MONOMETHYL ETHER)
CAS:34590-94-8
RTECS #:JM1575000
Fraction by Wt: 1%
OSHA PEL:S, 100 PPM
ACGIH TLV:S,100PPM/150 STEL
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 2%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:BRTHG HIGH CONCS OF VAPS/MISTS
MAY CAUSE IRRIT OF NOSE & THROAT, HDCH & NAUS. INGEST:INGEST OF
EXCESSIVE QTY MAY CAUSE IRRIT OF DIGESTIVE TRACT, SIGNS OF NERV SYS
DEPRESS (E.G., HDCH, DROW, DIZZ , LOSS OF COORD & FATG). PRLNGD &
RPTD INHAL, INGEST &/OR SKIN ABSORP MAY CAUSE DEGENERATION OF (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:KIDNEY & TO LESSER EXTENT, THE LIVER.
EYE CONTACT:SLIGHTLY IRRITATING. SKIN CONTACT:IRRITATION TO SKIN
UPON REPEATED OR PROLONGED CONTACT.
Medical Cond Aggravated by Exposure:RESPIRATORY SYMPTOMS ASSOCIATED
WITH PRE-EXISTING LUNG DISORDERS (E.G., ASTHMA-LIKE CONDITIONS) MAY
BE AGGRAVATED BY OVEREXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:MOVE SUBJECT TO FRESH AIR. EYE:FLUSH WITH A LARGE
AMOUNT OF WATER FOR AT LEAST 15 MINUTES. SEE A PHYSICIAN IF
IRRITATION PERSISTS. SKIN:WASH AFFECTED SKIN AREAS WITH SOAP AND
WATER. INGESTI ON:IF SWALLOWED, DILUTE BY GIVING 2 GLASSES OF WATER
TO DRINK. SEE A PHYSICIAN. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM AND/OR WATER
SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATERIAL CAN SPLATTER ABOVE 100C/212F.
POLYMER FILM CAN BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. FLOOR MAY BE SLIPPERY;
USE CARE TO AVOID FALLING. DIKE & CNTN SPILL W/INERT MATL (E.G.,
SAND, EARTH). TRANSFER LIQ TO CNTNRS FOR RECOVERY/DISP & SOLID
DIKING MATL TO SEPARATE CNT NRS FOR DISP. KEEP SPILL OUT OF SEWERS
& (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE TEMPERATURE MAX 49C/120F; MIN
1C/34F.
Other Precautions:KEEP FROM FREEZING-PRODUCT MAY COAGULATE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR SUITABLE RESPIRATOR (NIOSH/MSHA APPROVED OR
EQUIVALENT) WHERE EXPOSURE LIMITS ARE EXCEEDED.
Ventilation:LOCAL EXHAUST & MECHANICAL (GENERAL):YES.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING PROMPTLY AND WASH
AFFECTED SKIN AREAS WITH SOAP AND WATER. WASH CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
SPILL PROCESS:OPEN BODIES OF WATER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:VARIABLE
Vapor Pres:>17 @ 68F
Vapor Density:<1
Spec Gravity:1.04 (H*2O=1)
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:DILUTABLE
Appearance and Odor:ODORLESS, HEAVY BODIED, VARIOUS COLORS.
Percent Volatiles by Volume:38%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:TEMPERATURES ABOVE 177C/350F.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:COAGULATE THE EMULSION BY THE STEPWISE ADDITION
OF FERRIC CHLORIDE AND LIME. REMOVE THE CLEAR SUPERNATANT LIQUID
AND FLUSH TO A CHEMICAL SEWER. INCINERATE THE SOLIDS AND THE CONTAM
DIKING MATL AT PERM ITTED FACILITY ACCORD TO LOC, STATE & FED REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PENEPROOF PD-1A DEVELOPER
Kit Part:Y
CAGE:8P981
CAGE:8P981
CAGE:57869
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENTS(SIO*2,MGO,AL*2O*3)
Fraction by Wt: 5.0%
Ingred Name:CHLORINATED HYDROCARBON
Fraction by Wt: 75.0%
ACGIH TLV:350 PPM
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5.0%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15.0%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
===================== Hazards Identification =====================
Effects of Overexposure:BREATHING, LIGHT HEADEDNESS, EVENTUAL LOSS OF
CONSCIOUSNESS. SKIN CONTACT:WILL DRY SKINL
======================= First Aid Measures =======================
First Aid:REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2, FOAM
================== Accidental Release Measures ==================
Spill Release Procedures:ALLOW TO EVAPORATE, WIPE UP WITH RAGS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT. DO NOT USE NEAR
RED HEAT OR OPEN FLAME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CONFINED AREA USE WITH MASK WITH SEPARATE AIR
SUPPLY.
Ventilation:LOCAL EXHAUST IS PREFERRED
Supplemental Safety and Health
ITEM HAS 3 PARTS-PART A IS PENETRANT, PART B IS CLEANER, & PART C IS
DEVELOPER. PARTS A & B ARE COVERED UNDER NSN
6850-00-737-6912.KEY1:F1.
================== Physical/Chemical Properties ==================
HCC:V3
Vapor Pres:230
Vapor Density:4-5
Spec Gravity:1.3
Evaporation Rate & Reference:5.0
Solubility in Water:NEGLIGIBLE
Percent Volatiles by Volume:9.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WILL SOFTEN MANY MATERIALS:PLASTICS, RUBBERS, COATINGS.
Stability Condition to Avoid:VAPOR CONTACTING OPEN FLAME, RED HOT
SURFACES.
Hazardous Decomposition Products:HYDROCHLORIC ACID, PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:PUT IN AN APPROVED STORAGE CONTAINER & SHIP TO
AN APPROVED DISPOSAL AREA OR BURY IN AN APPROVED LANDFILL. DO NOT
PUNCTURE CANS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SOLVENT-DETERGENT
Preparer's Name:G. CHEKYIAN
CAGE:60115
CAGE:60115
============= Composition/Information on Ingredients =============
Ingred Name:NO HAZARDOUS INGREDIENTS LISTED FOR THIS PRODUCT.
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
======================= First Aid Measures =======================
First Aid:RINSE W/WATER FOR ACCIDENTAL EYE CONTACT.
===================== Fire Fighting Measures =====================
Flash Point:200F,93C
================== Accidental Release Measures ==================
Spill Release Procedures:CONSULT LOCAL ORDINANCES.
Neutralizing Agent:NOT REQUIRED
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO
Ventilation:NO
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NOT AVAIL
Decomp Temp:Decomp Text:NOT AVAIL
Spec Gravity:1.0
pH:10.5
Evaporation Rate & Reference:NOT AVAIL
Solubility in Water:COMPLETE
Appearance and Odor:PALE-YELLOW LIQUID.
Percent Volatiles by Volume:85.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NK
Hazardous Decomposition Products:CO2, NO2, N2O4.
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH INTO SEWER OR SEPTIC SYSTEM
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:REFRACTIVE INDEX LIQUIDS SERIES B, 19122
CAGE:IO084
CAGE:10684
CAGE:IO084
============= Composition/Information on Ingredients =============
Ingred Name:2-NAPHTHOL, 1-IODO-; (1-IODONAPHTHALENE)
CAS:2033-42-3
RTECS #:QL4150000
Other REC Limits:5 MG/M3 (MFR)
Ingred Name:1-BROMONAPHTHALENE
Other REC Limits:5 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE KNOWN AT CONDITIONS OF INTENDED
USE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:OILY FEEL, IF LIQUID IS MISTED OR ABOVE 150F
(NOT A CONDITION OF INTENDED USE) HEADACHES & NAUSEA POSSIBLE.
Medical Cond Aggravated by Exposure:NO DATA FOUND.
======================= First Aid Measures =======================
First Aid:INHAL: IF CONCERN ARISES REMOVE TO FRESH AIR AND ADMINISTER
OXYGEN OR ARTIFICIAL RESPIRATION. SKIN: PROMPT SOAP AND WATER WASH.
CALL MD IF SKIN IS IRRITATED. EYE: FLUSH WITH WATER FOR AT LEAST 15
MINU TES, SLIGHT TEMPORARY IRRITATION POSSIBLE. CALL MD. INGEST: DO
NOT INDUCE VOMITING. DRINK 1-2 GLASSES OF WATER OR MILK. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>199F,>93C
Extinguishing Media:CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:NONE. WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB, PLACE IN PLASTIC CONTAINER, CAP OR
TWIST TIE CLOSURE, WASH AREA WITH DETERGENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CONTACT WITH OXIDIZING
MATERIALS. STORE BETWEEN 39F AND 104F.
Other Precautions:AVOID CONTINUAL DIRECT LIGHT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST: MANDATORY IF A WORKER IS SENSITIVE TO ODOR.
OTHER: NORMAL ROOM AIR CHANGES/HR:2.
Other Protective Equipment:NOT MANDATORY EXCEPT AS GOOD LAB INDUSTRIAL
PRACTICES.
Work Hygienic Practices:ALWAYS USE GOOD HYGIENIC WORK/PRACTICES AS TO
HOUSEKEEPING, PERSONAL HYGIENE, USE OF CHEM LAB APRON, (SEE SUPP
DATA)
Supplemental Safety and Health
SKIN CONTACT.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>534F,>279C
Melt/Freeze Pt:M.P/F.P Text:39.0F,3.9C
Vapor Pres:1 (@ 73F)
Vapor Density:1 (@ 73F)
Spec Gravity:1.49-1.75
Evaporation Rate & Reference:1 (MINERAL OIL=1)
Solubility in Water:PRACTICALLY INSOL
Appearance and Odor:YELLOW OILY LIQUID; PUNGENT TO MOTH BALL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, HEAT ABOVE 150F. COMBUSTION WILL PRODUCE CARBON
DIOXIDE AND PROBABLY CARBON MONOXIDE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL CHEMICAL DISPOSAL MUST BE DISPOSED I/A/W
CURRENT LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:R7K6212 ACRYLIC ENAMEL REDUCER
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:WEIGHT PER GALLON IN POUNDS: 6.59
RTECS #:9999999WG
Ingred Name:TOTAL VOC LESS WATER & EXEMPT SOLVENTS: 6.59 LBS/GAL
RTECS #:9999999VO
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA *92/2*
CAS:64742-89-8
Fraction by Wt: 34%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 20%
Other REC Limits:375 MG/CUM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 4%
Other REC Limits:200 PPM
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTOXYETHANOL (ETHYLENEGLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 6%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:ACETONE; DIMETHYL KETONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 30%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYLENEGLYCOL MONOBUTYL ETHER ACETATE, BUTYL CELLOSOLVE
ACETATE, 2-BUTOXYETHYL ACETATE
CAS:112-07-2
RTECS #:KJ8925000
Fraction by Wt: 6%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION/RED/ITCHING/BURN.
SKIN: ABSORPTION/IRRITATION/RED/ITCHING/BURN. INHALATION:
RESPIRATORY IRRITATION/CNS
DEPRESSION/UNCONSCIOUSNESS/DEATH/HEADACHE/DIZZINESS/NAUSEA/LOSS OF
COORDINATION/A FFECTS
LIVER/URINARY/BLOOD-FORMING/CARDIOVASCULAR/REPRODUCTIVE
SYSTEM/HARMFUL/FATAL/PERMANENT BRAIN & CNS DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE: IRRITATION/RED/ITCHING & BURN. SKIN:
ABSORPTION/IRRITATION/RED/ITCHING & BURN. INHALATION: RESPIRATORY
IRRITATION/CNS
DEPRESSION/UNCONSCIOUSNESS/DEATH/HEADACHE/DIZZINESS/NAUSEA/LOSS OF
COORDINATI ON/AFFECTS
LIVER/URINARY/BLOOD-FORMING/CARDIOVASCULAR/REPRODUCTIVE
SYSTEM/HARMFUL/FATAL/PERMANENT BRAIN & CNS DAMAGE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:4F
Lower Limits:0.7%
Upper Limits:6.7%
Extinguishing Media:CO2, DRY CHEMICAL & FOAM
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. USE WATER USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. CLOSED
CONTAINERS MAY BUILD-UP PRESSURE, EXPLODE OR AUTOIGNITE WHEN
EXPOSED TO EXTREME HEAT. FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE W/INERT ABSORBENT. ELIMINATE IGNITION
SOURCES.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID INHALATION OF VAPOR OR SPRAY
MIST & CONTACT W/SKIN & EYES. KEEP CONTAINER CLOSED WHEN NOT IN
USE. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE &
APPROPRIATE LABELING. DON'T TAKE INTERNALLY. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING & INHALING THE CONTENTS CAN BE HARMFUL &
FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA.
Ventilation:LOCAL EXHAUST/GENERAL
Work Hygienic Practices:WASH HANDS AFTER USING. REMOVE/LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. DON'T SMOKE.
Supplemental Safety and Health
BOILING RANGE: 132-392F. REPORTS HAVE ASSOCIATED OVEREXPOSURE TO
SOLVENTS WITH PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE SUPP.
Vapor Density:>AIR
Spec Gravity:0.79-0.87
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN
FLAME, PILOT LIGHTS & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL BY INCINERATION IN COMPLIANCE W/LOCAL,
STATE, & FEDERAL REGULATIONS. DON'T INCINERATE CLOSED CONTAINER.
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE & APPROPRIATE
LABELING. WASTE FROM THIS PRODUCT MAY BE HAZARDOUS AS DEFINED
UNDER RCRA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SILVERSTONE FINISH, 456-295
CAGE:B0589
CAGE:B0589
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:SUPP DATA: SKIN IRRIT W/DISCOMFORT/RASH. CAN BE ABSORB THRU
SKIN IN HARMFUL AMTS. MAY CAUSE ABNORM KIDNEY FUNC. (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: ING 4:OVEREXP MAY CAUSE EYE, NOSE & THROAT IRRIT.
RPTD/PRLNGD LIQ CONT MAY CAUSE SKIN IRRIT & DERM. MAY (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:CAUSE CNS EFTS SUCH AS DIZZ, HDCH, NAUS & LOSS OF
CONSCIOUSNESS. CAUSES EYE CORR & PERM INJ.ING 5:OVEREXP(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:MAY CAUSE EYE, NOSE & THROAT IRRIT. RPTD/PRLNGD LIQ
CONT MAY CAUSE SKIN IRRIT & DERM. MAY CAUSE CNS EFTS (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: SUCH AS DIZZ, HDCH, NAUS & LOSS OF CONSCIOUSNESS.
RPTS HAVE ASSOC RPTD & PRLNGD OVEREXP TO SOLVS W/PERM (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: BRAIN & NERV SYS DMG. ING 6: CAUSES EYE CORR & PERM
INJ. CONT MAY CAUSE SKIN IRRIT WITH DISCOMFORT OR RASH.
RTECS #:9999999ZZ
Ingred Name:FLUOROPOLYMER SOLIDS
Ingred Name:MICA - SILICATES (< 1% CRYSTALLINE SILICA)
CAS:12001-26-2
RTECS #:VV8760000
OSHA PEL:20 MPPCF
ACGIH TLV:3 MG/M3 RDUST; 9293
Ingred Name:2-(2-BUTOXY ETHOXY) ETHANOL. VP: 0.01.
CAS:112-34-5
RTECS #:KJ9100000
Ingred Name:TRIETHANOLAMINE. VP: 0.01.
CAS:102-71-6
RTECS #:KL9275000
Ingred Name:AROMATIC HYDROCARBON. VP: 5.
CAS:64742-95-6
RTECS #:WF3400000
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:OCTYLPHENOXYPOLYETHOXYETHANOL (NONIONIC SURFACTANT)
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:PHOSPHORIC ACID (SARA III)
CAS:7664-38-2
RTECS #:TB6300000
OSHA PEL:1 MG/M3;3 PPM STEL
ACGIH TLV:1 MG/M3;3 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOS TO TEFLON DECOMP PRODS CAN
CREATE FLU-LIKE SYMPS, COMMONLY REFERRED TO AS POLYMER FUME FEVER.
SYMPS DO NOT ORDINARILY OCCUR UNTIL SEVERAL HRS AFTER EXPOS & PASS
W/IN 36-48 HRS. EFTS ARE NOT CUMU LATIVE. EXPOS USUALLY RSLTS FROM
SMOKING TOBBACO/CIGARETTES CONTAMD W/FLUOROCARBON DURING HNDLG/FROM
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: BRTHG VAPS EMITTED DURING BAKING.
INHAL: NORM NOT HAZ. PRODS CONTAIN SML AMTS OF SOLVS AS DESCRIBED.
SKIN/EYE: MAY CAUSE IRRIT/BURNING OF EYES. RPTD/PRLNGD LIQ CONT MAY
CAUSE SKIN IRRIT W/DI SCOMFORT & DERM. ING 1: HYDROGEN FLUORIDE IS
TOX & CAN CAUSE SKIN & EYE IRRIT (3PPM CEILING-ACGIH). HIGH CONCS
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION, PREFERABLY MOUTH-TO-MOUTH. IF BRTHG DFCLTY
PERSISTS, OR OCCURS LATER, CONSULT PHYSICIAN. SKIN: WASH WITH SOAP
& WATER. I F IRRITATION OCCURS, CONTACT PHYSICIAN.EYE: IMMED FLUSH
WITH PLENTY OF WATER FOR AT LEAST 15 MINS; CALL PHYS. INGESTION:
CALL PHYSICIAN IMMEDIATELY AND HAVE NAMES OF INGREDIENTS AVAILABLE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WATER FROM FOG NOZZLES MAY BE USED TO COOL
CLOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP.
Unusual Fire/Explosion Hazard:HYDROGEN FLUORIDE IS RELEASED DURING
FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
AVOID SKIN CONTACT AND BREATHING OF VAPOR. CONFINE AND REMOVE WITH
INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE LBL PRECS. KEEP AWAY FROM
HEAT, SPARKS & FLAME. CLOSE CNTNR AFTER EACH USE. GROUND CNTNRS
WHEN POURING. DO NOT STORE ABOVE 120F.
Other Precautions:EXPLO RXN MAY OCCUR >796F W/FINELY DIVIDED
FLUOROCARBON & METAL POWDER (ALUMINUM/MAGNESIUM). OPERS SUCH AS
GRINDING, BUFFING/GRIT BLASTING MAY GEN SUCH MIX. KEEP WET. USE
ADEQ VENT TO CNTRL. WASH THOR O AFTER HNDLG & BEFORE EATING &
SMOKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE VAPORS OR MISTS. WEAR PROPERLY
FITTED NIOSH/MSHA APPROVED VAP OR PARTICULATE RESP (TC-23C) FOR USE
WITH PAINTS DURING APPLIC AND UNTIL ALL VAPS & SPRAY MIST ARE
EXHAUSTED. FOLLOW RESP M FR'S DIRECTIONS FOR RESPIRATOR USE.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME AND PATTERN TO
KEEP CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING AND SMOKING.
Supplemental Safety and Health
% VOLAT: 44.4-49.7(WT). EFTS OF OVEREXP: CAN CAUSE LUNG DMG, PULM
EDEMA/BURNS. SOME VEGETATION IS PARTICULARLY SENSIT TO DMG BY HF &
ATTN MUST BE GIVEN TO EXHST LOCATIONS. ING 2:RPTD & PRLNGD OVEREXP
MAY LEAD TO CHRONIC LUNG DISEASE.ING 3:MAY CAUSE EYE IRRIT
W/DISCOMFORT, TEARING/BLURRED VISION. CONT MAY CAUSE (ING 10)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:APPRECIABLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:EXCEEDING RECOMMENDED BAKING TEMPERATURE
(>400C,>750F).
Hazardous Decomposition Products:AT TEMPS >400C (>750F) SML AMTS OF
HYDROGEN FLUORIDE CAN BE EVOLVED; AMTS INCR AS TEMP INCRS. OXIDES
OF HEAVY METALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. SEND TO HAZARDOUS WASTE WATER TREATMENT PLANT OR
INCINERATE ABSORBED MATERIAL IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REQUIREMENTS. DO NO T INCINERATE IN CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HYSOL EA 934NA QT SYSTEM, AS9174016
Kit Part:Y
Preparer's Name:MSDS DEPT
CAGE:33564
CAGE:33564
CAGE:3D523
============= Composition/Information on Ingredients =============
Ingred Name:POLYMER OF EPICHLOROHYDRIN, PHENOL-FORMALDEHYDE NOVOLAC
RESIN (ORAL RAT LD50=>4000 MG/KG)
CAS:28064-14-4
Fraction by Wt: 20-60%
Other REC Limits:NONE RECOMMENDED
Ingred Name:4-GLYCIDYLOXY-N,N-DIGLYCIDYLANILINE (ORAL RAT LD50 = 1000
MG/KG)(DERMAL RABBIT LD50 = >4000 MG/KG)
CAS:5026-74-4
Fraction by Wt: 15-40%
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOC = <10 G/L ESTIMATE
RTECS #:9999999VO
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:ALUMINUM POWDER (SARA 313) (ORAL RAT LD50 = >4000 MG/KG)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 10-30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:SILICA (DERMAL RABBIT LD50 = >4000 MG/KG)
CAS:112926-00-8
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:MIXTURE HAS NOT BEEN TESTED AS A WHOLE.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:BRIEF CONTACT MAY IRRIT SKIN OR CAUSE
A RASH. REPEATED OR PROLONGED SKIN CONTACT MAY RESULT IN ALLERGIC
SENSITIZATION. CARCINOGENICITY NOTE: BISPHENOL A/EPICHLOROHYDRIN
EPOXY RESIN HAS EXHIBITED MUTAG ENICITY IN BACTERIA.
Explanation of Carcinogenicity:NEITHER THIS MATERIAL NOR ANY OF IT'S
COMPONENTS IS CONSIDERED A CARCINOGEN.
Effects of Overexposure:SKIN RASH, IRRITATION.
Medical Cond Aggravated by Exposure:SKIN SENSITIZATION.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER FOR 15MINS. IF IRRIT PERSISTS GET MED ATTN.
SKIN:WASH THOROUGHLY W/SOAP & WATER. IF IRRIT PERSISTS GET MED
ATTN. INHAL:REMOVE VICTIM TO FRESH AIR. IF SYMPTOMS PERSIST GET MED
ATTN. I NGEST:DRINK PLENTY OF WATER. GET MED ATTN IMMED.
===================== Fire Fighting Measures =====================
Flash Point:NOT TESTED
Lower Limits:NOT TESTED
Upper Limits:NOT TESTED
Extinguishing Media:DRY CHEMICAL, OR HALON FIRE EXTINGUISHER, OR WATER
SPRAY, FOAM OR FOG.
Fire Fighting Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING, SUCH AS
TURN-OUT GEAR. CARTRIDGE RESP DO NOT PROVIDE ADEQUATE PROTECTION
FOR FIREFIGHTERS OR EXOTHERM MITIGATION.
Unusual Fire/Explosion Hazard:MAY LIBERATE LARGE QUANTITIES OF DENSE
FOUL-SMELLING SMOKE WHICH MAY CONTAIN UNIDENTIFIED TOXIC GASES.
================== Accidental Release Measures ==================
GLASSES. SCRAPE UP OR SHOVEL INTO DOT APPROVED WASTE CONTAINERS.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:REFRIGERATED STORAGE IS RECOMMENDED TO
MAINTAIN PRODUCT QUALITY. THIS PRODUCT MAY BE STORED @ 40F FOR UP
TO 12 MONTHS.
Other Precautions:FOLLOW CURING SCHEDULE AS RECOMMENDED IN PRODUCT
LITERATURE.DON'T CUT/GRIND/WELD/DRILL ON/NEAR CONTAINER.AVOID
MIXING PARTS A&B IN BATCHES >1LB UNLESS PLAN TO USE IMMED.DON'T
HEAT MIXED ADHESIVE >75F UNLESS CURING SURFACES TO BE BONDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UNNECESSARY WITH ADEQUATE EXHAUST VENTILATION.
Ventilation:LOCAL EXHAUST VENTILATION AT THE POINT OF USE.
Other Protective Equipment:AN EYEWASH AND SAFETY SHOWER SHOULD BE
NEARBY AND READY FOR USE.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING MATERIALS.
Supplemental Safety and Health
FAILURE TO OBSERVE PRECAUTIONS IN MIXING/HEATING MAY RESULT IN
EXCESSIVE HEAT BUILD-UP CAUSING AN EXOTHERM. THE EXOTHERM HAS
POTENTIAL FOR RELEASE OF TOXIC GASES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:UNDEFINED
Decomp Temp:Decomp Text:UNTESTED
Vapor Pres:NIL
Vapor Density:>1.0
Spec Gravity:1.59
Viscosity:*
Solubility in Water:NEGLIGIBLE.
Appearance and Odor:VISCOUS GRAY PASTE, SLIGHT ODOR
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:AVOID MIXING RESIN & CURING AGENT IN
BATCHES >1 LB. UNLESS YOU PLAN TO USE IMMEDIATELY, DON'T HEAT MIXED
ADHESIVE >120F.
Hazardous Decomposition Products:CO, NOX, ALDEHYDES, ACIDS &
UNDETERMINED ORGANICS.
Conditions to Avoid Polymerization:POLYMERIZATION NOT LIKELY
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT RCRA HAZ WASTE.HOWEVER, INCINERATION IN EPA
APPROVED WASTE INCINERATOR IS PREFERRED.CHEM ADDITIONS/
PROCESSING/OTHERWISE ALTERING MATL MAY MAKE WASTE MANAGEMENT INFOR
HEREIN INCOMPLETE/INACCURATE/ INAPPROPRIATE.CONSULT STATE/LOC
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:IBM, SOLVENT, ANTI STATIC LIQUID
CAGE:7N876
CAGE:60777
CAGE:7N876
CAGE:30874
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 89%
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 11%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:
INHALATION/INGESTION-DRUNKENNESS, DROWSINESS, INCOORDINATION.
EYE/SKIN-MILD IRRITATION. CHRONIC: INHALATION-DROWSINESS OR
DRUNKENNESS.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:OBTAIN MEDICAL ATTENTION. INGESTION: IF CONSCIOUS & IF THERE
ARE NO SIGNS OF CONVULSIONS/GAG REFLEX IMPAIRMENT, INDUCE VOMITING.
INHALATION: REMOVE FROM EXPOSURE. IF BREATHING IS DIFFICULT/ABSENT,
PRO VIDE CARDIOPULMONARY SUPPORT. EYE: FLUSH WITH WATER FOR 15
MINUTES. SKIN: WASH WITH MILD SOAP & WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:53.1F,11.7C
Autoignition Temp:Autoignition Temp Text:399C
Lower Limits:2.5
Upper Limits:12
Extinguishing Media:CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WATER SPRAY DOES NOT EFFECTIVELY EXTINGUISH A
FIRE, BUT WILL HELP TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:HIGHLY FLAMMABLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. VENTILATE
AREA. AVOID BREATHING OF VAPORS. COVER WITH ABSORBENT MATERIAL,
COLLECT THE MIXTURE AND PLACE IN A CLOSED CONTAINER FOR PROPER
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED. STORE
AWAY FROM HEAT, SPARKS OR OPEN FLAMES.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF LEVELS EXCEED THE RECOMMENDED HEALTH
STANDARDS, WEAR A NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR. FOR
EMERGENCY USE, WEAR A NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:IF LEVELS EXCEED THE RECOMMENDED HEALTH STANDARDS, USE
LOCAL EXHAUST OR GENERAL DILUTION VENTILATION.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWERS SHOULD BE
AVAILABLE IN THE IMMEDIATE VICINITY OF ANY POTENTIAL EXPOSURE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, DRINKING, SMOKING, OR
USING TOILET FACILITIES. WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:180F,82C
Vapor Pres:33
Spec Gravity:0.3
Evaporation Rate & Reference:21 (NOT GIVEN)
Solubility in Water:100%
Appearance and Odor:CLEAR, WATER WHITE LIQUID; SWEET ALCOHOL ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS.
Stability Condition to Avoid:HEAT, OPEN FLAMES, SPARKS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
UNIDENTIFIED ORGANICS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. USE CERTIFIED VENDOR FOR DISPOSAL BY
INCINERATION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BLUE THUNDER FLOOR FINISH, 105890
CAGE:61781
CAGE:61781
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-(2-METHOXYETHOXY)-; (DEG METHYL ETHER). VP:115
CAS:111-77-3
RTECS #:KL6125000
Fraction by Wt: 4%
OSHA PEL:35 (HH3) (MFR)
ACGIH TLV:25 (HH3) (MFR)
Ingred Name:PHTHALIC ACID, DIBUTYL ESTER; (DIBUTYL PHTHALATE) (SARA
313) (CERCLA). VP:0.3
CAS:84-74-2
RTECS #:TI0875000
Fraction by Wt: 2%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:AMMONIUM HYDROXIDE (CERCLA)
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: 1.4%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SKIN:REDNESS AND DRYING.
EYES:DISCOMFORT, REDNESS, AND MODERATE IRRITATION. INGESTION:SLIGHT
MUCOSAL DAMAGE ALONG WITH STOMACH CRAMPS, NAUSEA AND/OR VOMITING.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . SKIN:WASH THOROUGHLY WITH WATER. IF IRRITATION PERSISTS,
CALL PHYS. EYES:FLUSH W/WATER FOR @ LEAST 15 MINUTES. CALL PHYS IF
IR RIT CONTINUES. INGEST:IMMED DRINK LARGEQUANTITIES OF WATER.
CONTACT PHYS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CO*2, WATER MIST, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:NONE. USE NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP W/DAMP MOP, SPONGE OR RAGS, AND
DISCARD. FLUSH AREA W/CLEAN WATER IF NECESSARY. AVOID DISCHARGE
INTO OPEN WATERWAYS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE OR STACK OVER THREE CASES
OR PAILS HIGH.
Other Precautions:PLEASE READ AND FOLLOW DIRECTIONS ON PRODUCT LABEL.
THEY ARE YOUR BEST GUIDE FOR THIS PRODUCT IN THE MOST EFFECTIVE
WAY, AND THEY ALSO GIVE NECESSARY SAFETY PRECAUTIONS TO PROTECT
YOUR HEALTH.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:210F,99C
Vapor Pres:SEE INGS
Vapor Density:N/S
Spec Gravity:1.005
pH:8.6
Evaporation Rate & Reference:<1 (WATER =1)
Solubility in Water:YES
Appearance and Odor:MILKY WHITE EMULSION WITH SLIGHT AMMONIACAL ODOR.
Percent Volatiles by Volume:44-46
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:SM SPILLS MAY BE FLUSHED INTO SEWER SYSTEMS. LG
SPILLS SHOULD BE CONTAINED W/ABSORBENT MATERIAL & DISCARDED IN
ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:28F18
CAGE:24454
CAGE:24454
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:V1
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MAX-ABRADE SD ELECTRODE, 17610250
Preparer's Name:B ABBOTT
CAGE:JO676
CAGE:55649
CAGE:JO676
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:C 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON. LD50: (ORAL,RAT) 30 G/KG
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:10 PPM.
ACGIH TLV:10 PPM.
Ingred Name:CARBON
CAS:7440-44-0
RTECS #:FF5250100
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:BORON
CAS:7440-42-8
RTECS #:ED7350000
OSHA PEL:10 MG B203/M3
ACGIH TLV:10 MG B2O3/M3
Ingred Name:CALCIUM CARBONATE. LD50: (ORAL,RAT) 6450 MG/KG
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:PHENOL FORMALDEHYDE RESIN; (PHENYL FORMALDEHYDE)
CAS:9003-35-4
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FELDSPAR; (POTASSIUM FELDSPAR)
CAS:68476-25-5
OSHA PEL:2 MG/KG (MFR)
ACGIH TLV:10 MG/KG (MFR)
Ingred Name:GRAPHITE; (CALCIUM FLUORIDE). LD50: (ORAL,RAT) 4250 MG/KG
CAS:7782-42-5
RTECS #:MD9659600
OSHA PEL:15 MPPCF; Z-3
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICA, QUARTZ)
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:VANADIUM (SARA 313)
CAS:7440-62-2
RTECS #:YW1355000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FORMALDEHYDE (SARA 302/313) (CERCLA)
CAS:50-00-0
RTECS #:LP8925000
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM, A2
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SUPDAT: WELDERS HEAD IN RELATION TO FUME PLUME & PRESENCE
OF ATM CONTAMINANTS. WHEN FILLER METAL IS CONSUMED, (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: DECOMP PRODS GENERATED ARE DIFFERENT IN PERCENT &
FORM FROM INGREDS. DECOMP PRODS FROM NORM OPERATION (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: INCL THOSE ORIGINATING FROM VOLITALIZATION
RXN/OXIDATION OF ELECTRODE, PLUS THOSE FROM BASE METAL & (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: COATING. CHRONIC: OVEREXP TO WELDING FUMES CAN LEAD
TO SIDEROSIS (IRON DEPOSITS IN LUNGS) WHICH AFFECT (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: PULM FUNCTION. TARGET ORGANS: LUNGS. FOR MORE
SPECIFIC INFORMATION CONT NEHC .
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: GIVE FLUIDS AGAIN. GET IMMED MEDICAL
ATTENTION.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: OR PROD IS USED & LBLD FOR FACILITY GROUNDS
MAINTENANCE (SUCH AS FERTILIZERS & HERBICIDES), OR PROD (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: IS USED & LABELED FOR MAINTAINING MOTOR VEHICLES.
CALIFORNIA PROP 65: WARNING: THIS PROD CNTNS FOLLOWING(ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22: CHEM(S) KNOWN TO STATE OF CALIFORNIA TO CAUSE (1)
CANCER OR (2) BIRTH DEFECTS/OTHER REPRO HARM: SILICA, (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: QUARTZ (1), CHROMIUM (1).
RTECS #:9999999ZZ
Ingred Name:VENT: TRAIN WELDOR TO KEEP HEAD OUT OF FUMES.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS 4, 8, & 11
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: EYES: FUMES & GASES MAY CAUSE
IRRIT TO EYES. ARC RAYS CAN BURN/INJURE EYES. SKIN: ARC RAYS CAN
BURN/INJURE SKIN. INHAL: FUMES & GASES MAY CAUSE DIZZ, NAUS,
DRYNESS/IRRIT OF NOSE & THROAT. ELEC SHOCK CAN KILL. OVEREXP TO
MANGANESE CMPDS MAY AFFECT CNS. SYMPS INCL MUSCULAR WEAK & TREMORS
SIMILAR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC MONO,
VOL 68, 1997: GROUP 1. NTP 7TH ANNUAL RPT ON CARCIN, 1994: ANTIC TO
BE (SUPDAT)
Effects of Overexposure:EFTS OF OVEREXP: TO PARKINSON'S. TOX INFO:
WELDING & BRAZING FUMES CANNOT BE CLASSIFIED SIMPLY. COMPOSITION &
QTY ARE DEPENDENT ON METAL BEING WELDING, PROCESS, PROC, & FILLER
METALS USED. OTHER CNDTN S INFLUENCING COMPOSITION & QTY OF FUMES &
GASES THAT WORKERS MAY BE EXPOS TO INCL: COATINGS ON WELDED METAL,
(SUPDAT)
Medical Cond Aggravated by Exposure:MAY AGGRAVATE INDIVIDUALS WITH
EXISTING RESPIRATORY OR ALLERGIC CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SEEK MED ATTN IF RESP IRRIT
DEVELOPS/IF BRTHG BECOMES DFCLT. EYE: RINSE W/WATER. REMOVE ANY
CONT LENSES & CONTINUE FLUSHING W/PLENTY OF WATER FOR @ LST 15
MINS. SEEK MED AT TN IF IRRIT DEVELOPS. SKIN: WASH AREAS W/PLENTY
OF SOAP & WATER FOR SEVERAL MINS. SEEK MED ATTN IF IRRIT DEVELOPS.
INGEST: GIVE 3-4 GLASSES OF WATER, BUT DO NOT INDUCE VOMIT. IF
VOMIT OCCURS (ING 20)
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . DO NOT
USE WATER ON MOLTEN METAL, AS HAZ METAL FUMES MAY BE PRODUCED. USE
WATER ON SOLID METAL TO KEEP IT (SUPDAT)
Unusual Fire/Explosion Hazard:WELDING ARC & SPKS CAN IGNITE
COMBUST/FLAMM MATLS. REFER TO AMERICAN NATIONAL STANDARD 149.1, FOR
FIRE PREVENTION DURING WELDING PROCEDURES.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP PRODUCT. SWEEP AND MOP AREA AS
REQUIRED.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT TOUCH LIVE ELECTRICAL PARTS.
INSULATE FROM WORK AND GROUND. READ THE ENTIRE LABEL BEFORE USING
THIS PRODUCT. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:WEAR HEAD, HAND & BODY PROT WHICH HELPS TO PVNT
INJURY FROM RADIA, SPKS & ELEC SHOCK. IF UE (USE EMEMPTION) APPEARS
UNDER UPPER % LIMIT, END USERS ARE EXEMPT FROM NOTIFICATION BECAUSE
PROD IS USED & L BLD FOR ROUTINE JANITORIAL WORK,(ING 21)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPRVD OR EQUIVALENT FUME RESPIRATOR
OR AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACE, OR WHERE
LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:USE ENOUGH VENT, LOC EXHAUST AT ARC/BOTH TO KEEP FUMES &
GASES BELOW TLV'S IN WORKERS BRTHG ZONE & GEN AREA. (ING 25)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
WELDING PROTECTIVE CLOTHING. ALL SKIN AREA SHOULD BE COVERED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: COOL IN FIRE SITUATIONS. EXPLAN OF CARCIN: CARCIN.
FORMALDEHYDE: IARC MONO. SUPP, VOL 7, PG 211, 1987: GROUP 2A. NTP
7TH ANNUAL RPT ON CARCINS, 1994: ANTIC TO BE CARCIN. OSHA REGULATE
D CFR 29 1910.1048. EFTS OF OVEREXP: NUMBER OF WELDERS & VOL OF
WORK AREA. QTY OF AMT OF VENT, POSITION OF (ING 15)
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:OPAQUE, MAROON FLUX COATED SOLID METAL. NO ODOR.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:FLUORIDES, COMPLEX OXIDES OF METALS.
OXIDES OF CARBON AND NITROGEN, AND OZONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WTIH ALL FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1462 CAL STAT
Preparer's Name:M EBERS
CAGE:GO534
CAGE:GO534
CAGE:21667
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL(IARC CANCER REVIEW GROUP 3) *96-2*
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 60%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(LAB ANIMAL): 5.84 G/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CAUSES IRRITATION,
CONJUNCTIVITIS & POSSIBLE CORNEAL ULCERATION. INGESTION: MAY CAUSE
NAUSEA/VOMITING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:53F
Extinguishing Media:WATER, DRY CHEMICAL, CO2/ALCOHOL FOAM
Fire Fighting Procedures:EXERCISE CAUTION WHEN FIGHTING ANY CHEMICAL
FIRE. RESPIRATORY PROTECTION IS ESSENTIAL.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AREA TO CONTAIN MATERIAL AS POSSIBLE.
REMOVE ANY REMAINING MATERIAL BY ABSORBING ON VERMICULITE/OTHER
SUITABLE MATERIAL & PLACE IN SEALED CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:USE IN ONLY WELL VENTILATED AREAS.
DON'T STORE AT TEMPS <32F. KEEP OUT OF REACH OF CHILDREN. FOR
EXTERNAL USE ONLY
Other Precautions:READ & OBSERVE ALL LABELED PRECAUTIONS. DON'T USE
IN/NEAR THE EYES. FUMES MAY BE TOXIC.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:LOCAL & MECHANICAL EXHAUST
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:194F
Vapor Pres:43
Vapor Density:3.5
Spec Gravity:0.887
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR BLUE LIQUID W/ALCOHOL ODOR
Percent Volatiles by Volume:98/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:FIRE/FLAME
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE/DISPOSE OF IN ACCORDANCE W/LOCAL,
STATE & FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:GENESOLV 2010, MCC-2010
CAGE:DO807
CAGE:0ATV9
CAGE:DO807
============= Composition/Information on Ingredients =============
Ingred Name:FIRST AID PROC:& SHOES. INGEST: IF CONSCIOUS, GIVE 2-4
GLASSES OF WATER & INDUCE VOMITING BY TOUCHING FINGER (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: TO BACK OF THROAT. DO NOT GIVE STIMULANTS. CONTACT
PHYSICIAN IMMEDIATELY.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: PROT PERSONNEL SHOULD REMOVE IGNITION SOURCES &
SHUT OFF FIRE-SOURCES. PROVIDE VENT. SHOVEL (SPARK (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: PROOF) ABSORBENT MATERIAL INTO DRUMS AND CLOSE. DO
NOT FLUSH TO SEWER.
RTECS #:9999999ZZ
Ingred Name:GENESOLV 2010
Fraction by Wt: 90%
Ingred Name:CHLORODIFLUOROMETHANE
CAS:75-45-6
RTECS #:PA6390000
Fraction by Wt: 10%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ozone Depleting Chemical:2
Ingred Name:1,1-DICHLORO-1-FLUOROETHANE
CAS:1717-00-6
RTECS #:KI0997000
Fraction by Wt: 96.0%
Ozone Depleting Chemical:2
Ingred Name:1,1-DICHLORO-2,2,-TRIFLUOROETHANE
CAS:306-83-2
RTECS #:KI1108000
Fraction by Wt: 10%
Ozone Depleting Chemical:2
Ingred Name:METHYL ALCOHOL; (METHANOL)(SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 3.6%
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NITROMETHANE
CAS:75-52-5
RTECS #:PA9800000
Fraction by Wt: 0.3%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:SUPP DATA:EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR
LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: EXPOSED TO CHLOROFLUOROCARBONS .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:AT LOW CONC LEVLS: DROWS,
FLUSHING, HDCH, DIZZ, LOSS OF CONC, NAUS & IRRIT. AT HIGH LEVSL.
INTOX & CARDIAC ARRHYTHMIA. PROD VAPS DISPLACE AIR & CAN CAUSE
ASPHYXIATION ESPECIALLY IN CONFINED SPAC ES. INGEST:SIMILAR TO
INHAL. DISCOMFORTDUE TO VOLATILITY WOULD BE EXPECTED. ALSO,
INSUFFICIENT QTYS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CAN CAUSE EYE DAMAGE INCL BLINDESS DUE
TO METHANOL COMPONENT. SKIN:DEFATTING OF SKIN CAN CAUSE IRRIT. NO
ABSOP TOX DATA IS AVAIL. EYES: PERSONS WEARING CONTACT LENSES SHLD
WEAR CHEM PROT SAFE TY GLASSES WHEN USING THIS PROD. LIQ CNTCT:
WILL IRRIT EYES & MAY CAUSE CONJUNCTIVITIS. VAP CNTCT:MILD
IRRIT.(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. DO NOT GIVE EPINEPRHINE. GIVE ARTF
RESP IF NEC. CALL MD. EYE/SKIN: PERSONS W/CONTACT LENSES SHOULD
WEAR CHEMICAL PROT SAFETY GLASSES WHEN USING THIS PRODUCT. FLUSH
W/WATER F OR @ LST 15 MIN, LIFTING EYELIDS OCCASIONALLY UNTIL NO
EVIDIENCE OF THE CHEM REMAINS. IF IRRIT PERSISTS CALL MD. SKIN:
WASH PROMPTLY W/SOAP & WATER FOR AT LEAST 15 MIN. REMOVE CONTAM
CLTHG (ING 9)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Lower Limits:8%
Upper Limits:19.0%
Extinguishing Media:CO*2, DRY CHEMICAL OR H*2O.
Fire Fighting Procedures:KEEP CONTIANERS COOL WITH WATER SPRAY. WEAR
NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CNTNRS GENERATE PRESS WHEN HEATED CAUSING
VIOLENT BURSTING & DANGEROUS PROPELLING OF CNTNRS.FORMS TOX DECOMP
PROD >250F.THERMAL DECOMP PRODS MAY INCL(SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:ALTHOUGH THE CHANCES OF A SIGNIFICANT
SPILL/LEAK IS UNLIKELY IN AEROSOL CNTNRS, IN THE EVENT OF SUCH AN
OCCURENCE, EVAC AREA, ABSORB SPILLED LIQ W/COMMERCIALLY,
NON-FLAMMABLE ABSORBANT, I.E. SAND, VER MICULITE. REMOVE
UNPROTECTED PERSONNEL.(ING 11)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BRTHG VAPS. USE ONLY W/ADEQUATE
VENT. AVOID LIGHTED CIGARETTES, FLAME, WELDING/HOT SPOTS WHICH MAY
GENERATE TOXIC DECOMP PRODUCTS.
Other Precautions:VAPS ARE HEAV & MAY CONC IN LOW POORLY VENT AREAS. NO
SMOKING IN AREA OF USE. DO NOT USE IN GEN VICINITY OF ARC WELDING,
OPEN FLAMES OR HOT SURFACES. HEAT AND/OR UV RADIATION MAY CAUSE THE
FORMATION O F CHLORIDES, FLUORIDES, PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IN VENT WORK AREAS. ALTHOUGH
UNLIKELY IN AEROSOL PACAGING, USE NIOSH/MSHA APPROVD SELF-CONTAINED
OR SUPPLIED AIR RESPIRATORS FOR EMERGENCIES AND IN SITUATIONS WHERE
AIR MAY BE DISPLACED BY VAPORS.
Ventilation:ADEQUATE. LOCAL EXHAUST: FOR POORLY VENTILATED WORK AREAS.
MECH: ADEQUATE FOR STORAGE.
Other Protective Equipment:PROTECTIVE CLOTHING FOR PROLONGED OR
REPEATED CONTACT PVA OR NEOPRENE PREFERRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:CHLORIDES, FLUORIDES & PHOSGENE . MATLS TO AVOID: MOLTEN
ALUMINUM, BARIUM & LITHIUM SHAVINGS. STRONG OXIDIZING AGENTS. EFTS
OF OVEREXP:CHLROFLUOROCARBON MATLS HAVE PRODUCED SENSIT OF T HE
MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE A SIMILAR EFT
IN HUMANS. ADRENOMIMETICS (E.G., (ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:85.6F,29.8C
Vapor Pres:10 @ 70F
Vapor Density:4.05
Spec Gravity:1.21 (H*2O=1)
Evaporation Rate & Reference:>1 (ETHER=1)
Solubility in Water:BELIEVED SLIGHT
Appearance and Odor:COLORLESS, LIQUID WITH ETHEREAL AND FAINT SWEETISH
ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & ALKALIS, REACTIVE METALS E.G. POWDERED ALUMINUM, SODIUM,
POTASSIUM, CALCIUM MAGNESIUM, ZINC, (SUPP DATA)
Stability Condition to Avoid:HEAT WILL DECOMPOSE ABOVE 250 F.
Hazardous Decomposition Products:HYDROCHLORIC AND HYDROFLUORIC ACIDS,
AND CARBONYL HALIDES SUCH AS PHOSGENE. CHLORIDES, FLUORIDES .
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH FEDERAL, STATE & LOCAL REGULATIONS.
CONSULT APPROPRIATE REGULATORY AGENCY PRIOR TO DISPOSAL OR
DISCHARGE OF WASTE MATERIAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ALKYD ENAMEL UNDERBODY, C217
CAGE:09585
CAGE:09585
CAGE:91950
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT. VP:2 @ 20C.
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 31.9%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:MAGNESIUM ALUMINUM SILICATE
CAS:12174-11-7
RTECS #:RT6400000
Fraction by Wt: 1.5%
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 3.4%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:TITANIUM OXIDE;(TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 13.7%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CALCIUM CARBONATE
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 46.6%
Ingred Name:SILICA GEL
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 1.6%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:HARMFUL IF INHALED. MAY
AFFECT BRAIN OR NERV SYS CAUSING DIZZ, HDCH OR NAUS. EYE:IRRIT.
SKIN:IRRIT. INGEST:IRRIT OF DIGESTIVE TRACT & NERV SYS DEPRESS
(DROWS, DIZZ, LOSS OF COORD & FATIGUE ). ASPIR HAZ-MATL CAN ENTER
LUNGS DURING SWALLOWING OR VOMIT & CAUSE LUNG INFLAMM & DMG.
CHRONIC:SKIN:(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA QUARTZ GROUP 2A
(IARC), ANTIC TO BE A CARCIN (NTP).
Effects of Overexposure:HLTH HAZ::PRLNGD/RPTD EXPOS MAY CAUSE DERM.
INHAL:SANDING DUST INHAL MAY CAUSE LUNG DMG. NOTICE:REPORTS HAVE
ASSOC PERM BRAIN & NERV SYS DMG W/RPTD PROLONGED EXPOS TO SOLV
AMONG PERS ENGAGED IN PAINTI NG TRADE. INTENTIONAL MISUSE BY DELIB
CONCENTRATING & INHALING CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:NONE EXPECTED.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE FROM HAZARD AREA, MAINTAIN BREATHING, CALL MD.
SKIN:REMOVE WITH SOAP & WATER. EYE:FLUSH IMMEDIATELY WITH LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. CALL MD. INGEST:DRINK 1
OR 2 GLASSES OF WATER TO DILUTE. DO NOT INDUCE VOMITING. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:127F,53C
Lower Limits:0.6%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . DO NOT USE WATER STEAM OR BURNING LIQUID.
COOL EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE. TOXIC GASES MAY FORM WHEN PRODUCT BURNS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. USE NON-SPARKING TOOLS TO RETURN MATERIALS TO
CONTAINER. ABSORB RESIDUE WITH FULLER'S EARTH.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:COMBUSTIBLE-KEEP AWAY FROM HEAT AND
FLAME.
Other Precautions:USE ONLY WITH ADEQUATE VENTILATION. AVOID PROLONGED
CONTACT WITH SKIN AND BREATHING OF VAPOR OR SPRAY MIST OR SANDING
DUST. CLOSE CONTAINER AFTER EACH USE. KEEP OUT OF REACH OF
CHILDREN. DO NOT TAKE I NTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR SPECIFIED FOR
PROTECTION AGAINST PAINT SPRAY MIST, SANDING DUST AND ORGANIC
VAPORS IN RESTRICTED OR CONFINED AREAS.
Ventilation:ADEQ TO MAINTAIN WORKING ATMOSPHERE BELOW TLV/LEL. MECH
EXHST MAY BE REQ IN CONFINED AREAS. DISCHARGE EXHST (SUPDAT)
Other Protective Equipment:CLOTHING ADEQUATE TO PROTECT SKIN.
Work Hygienic Practices:REMOVE AND WASH CLOTHING BEFORE REUSE. WASH
HANDS BEFORE EATING, SMOKING OR USING THE WASHROOM.
Supplemental Safety and Health
VENT:ONLY IN AREA AWAY FROM IGNITION SOURCES.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>370F,>188C
Vapor Pres:SEE ING 1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORSEEABLE.
Stability Condition to Avoid:ELEVATED TEMPERATURES AND BUILDUP OF
VAPORS.
Hazardous Decomposition Products:BURNING MAY PRODUCE CARBON DIOXIDE AND
CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONVENTIONAL PROCEDURES IN COMPLINACE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED
CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ATOMIC ABSORPTION STANDARD, AQU2-100
Preparer's Name:VANAJA SIVAKUMAR
CAGE:07977
CAGE:07977
============= Composition/Information on Ingredients =============
Ingred Name:NITRIC ACID; (HNO*3) (SARA III) (CONTAINING ING 2)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 2%
OSHA PEL:2 PPM
ACGIH TLV:2 PPM;4 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:URANIUM. %:1,000 PPM.
CAS:7440-61-1
RTECS #:YR3490000
Fraction by Wt: <0.1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EFTS OF OVEREXP:CAUSING SPASM, INFLAMM & EDEMA OF LARYNX &
BRONCHI, CHEM PNEUM & PULM EDEMA. SYMPS INCL; BURNING (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:SENSATION, COUGHING, WHEEZING, LARYNGITIS, SHORTNESS
OF BREATH, HEADACHE, NAUSEA & VOMITING.
RTECS #:9999999ZZ
Ingred Name:OTHER PROTECTIVE EQUIPMENT: IN CASE OF EMERGENCY. WEAR
CHEMICAL RESISTANT CLOTHING. LABORATORY COAT.
RTECS #:9999999ZZ
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SYMPS & HLTH HAZ FOR DILUTE NITRIC
ACID ARE EXPECTED TO BE LESS SEV THAN EXPOS TO CONC NITRIC ACID.
CONC NITRIC ACID MAY BE FATAL IF TOO MUCH IS INHALED/ABSORBED THRU
SKIN. CONC NITRIC ACID VAP/MIST I S IRRIT OF EYES, MUC MEMBS &
SKIN. IN CONT W/EYES, IT PRDCES SEV BURNS WHICH MAY RSLT IN PERM
DMG & (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:VISUAL IMPAIRMENT. ON SKIN, LIQ/CONC
VAP PRDCES IMMED, SEV & PENETRATING BURNS. CONC SOLNS CAUSE DEEP
ULCERS & STAIN SKIN A BRIGHT YELLOW/YELLOWISH BROWN COLOR. VAP &
MIST MAY ERODE EXPOS TEE TH W/PRLNG EXPOS. INGEST OF LIQ WILL CAUSE
IMMED PAIN & BURNS OF MOUTH, ESOPHAGUS & GI TRACT. INHAL MAY BE
FATAL (ING 3)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER FOR AT LEAST 15 MINUTES OCCASIONALLY
LIFTING UPPER & LOWER EYELIDS. SKIN:REMOVE CONTAMINATED CLOTHING,
THEN FLUSH W/WATER FOR AT LEAST 15 MINUTES. WASH CLOTHING
THOROUGHLY BEFORE RE USE. INHAL:MOVE TO FRESH AIR. INGEST:DONOT
INDUCE VOMITING. IMMED OBTAIN MED HELP. SEND TO HOSPITAL. ONLY IF
PATIENT IS CONSCIOUS, GIVE LG QTYS OF WATER/MILK. IF IRRIT
CONTINUES, GET MED ATTN IMMED.
===================== Fire Fighting Measures =====================
Extinguishing Media:APPROPRIATE TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CONC HNO*3 REACTS EXPLOSIVELY W/COMBUST
ORGANIC/READILY OXIDIZABLE MATLS SUCH AS; ALCOHOL, WOOD,
TURPENTINE, METAL PWDRS, HYDROGEN SULFIDE, ETC. CONC (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. DILUTE SPILL W/WATER & NEUT W/SODA
ASH, LIMESTONE, ETC. WIPE UP & PUT INTO SEALED CNTNR FOR PROPER
DISP. WASH SPILL SITE OFF W/WATER AFTER MATL PICK UP IS COMPLETE.
RESP.
Neutralizing Agent:SODA ASH, LIMESTONE, ETC.
======================Handling and Storage ======================
Handling and Storage Precautions:CONCENTRATED NITRIC ACID WILL ATTACK
SOME FORMS OF PLASTICS, RUBBER & COATINGS. STORE AT ROOM
TEMPERATURE. KEEP TIGHTLY SEALED WHEN NOT IN USE.
Other Precautions:IRRITANT, OXIDIZER & CORROSIVE LIQUID. AVOID
INHALATION, INGESTION & CONTACT W/EYES & SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE IN A CHEMICAL FUME HOOD.
Other Protective Equipment:DELUGE SHOWER WHICH MEETS ANSI DESIGN
CRITERIA . HAVE IMMED AVAILABILITY OF AN ANSI APPROVD DESIGN EYE
WASH(ING 5)
Work Hygienic Practices:WASH CAREFULLY AFTER USE.
Supplemental Safety and Health
EXPLO HAZ:HNO*3 IS NOT COMBUST, BUT IS STRONG OXIDIZER & ITS HEAT OF
RXN W/REDUCING AGENTS/COMBUSTS MAY CAUSE IGNIT. CAN REACT W/METALS
TO RELS FLAMM HYDROGEN GAS. MATLS TO AVOID:AS; ALCOHOL, WOOD, TU
RPENTINE, METAL PWDRS, HYDROGEN SULFIDE, ETC. CONT W/STRONG BASES
WILL CAUSE VIOLENT SPLATTERING.
================== Physical/Chemical Properties ==================
HCC:D4
Spec Gravity:1
Solubility in Water:SOLUBLE
Appearance and Odor:TRANSPARENT W/ACRID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONC HNO*3 IS POWERFUL OXIDIZING AGENT. IT REACTS EXPLOSIVELY W/COMBUST
ORGANIC/READILY OXIDIZABLE MATLS SUCH (SUPDAT)
Stability Condition to Avoid:ELEVATED TEMPERATURE MAY CAUSE CONTAINERS
TO BURST & LIBERATE TOXIC OXIDES OF NITROGEN.
Hazardous Decomposition Products:WILL RELEASE TOXIC NITROGEN OXIDE
FUMES & VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT LOCAL, STATE & FEDERAL HAZARDOUS OR
CHEMICAL WASTE DISPOSAL AGENCY FOR REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:21-641 FORMALIN 10% NEUTRAL
CAGE:7V410
CAGE:7V410
============= Composition/Information on Ingredients =============
Ingred Name:FORMALDEHYDE
CAS:50-00-0
RTECS #:LP8925000
= Wt:10.
OSHA PEL:see 1910.1048
ACGIH STEL:C0.37 MG/M3;C0.3 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 500 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES OSHA:YES
Health Hazards Acute and Chronic:HARMFUL/FATAL IF SWALLOWED,
INHALED/ABSORBED THROUGH SKIN. SENSITIZER, MAY CAUSE
HYPERSENSITIVITY/IRRITATION TO SKIN, EYES & RESPIRATORY TRACT.
Explanation of Carcinogenicity:FORMALDEHYDE: ACGIH-SUSPECTED
CARCINOGEN, IARC-PROBABLE CARCINOGEN (GROUP 2-A HUMAN EVIDENCE
LIMITED, ANIMAL EVIDENCE SUFFICIENT), OSHA-SPECIFICALLY REGULATED
CARCINOGEN.
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN/RESPIRATORY
DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH IMMEDIATELY W/COPIOUS AMOUNTS OF WATER FOR
15 MINS. INGESTION: GIVE LARGE QUANTITY OF WATER, ACTIVATED
CHARCOAL/MILK & INDUCE VOMITING BY STICKING FINGER DOWN THROAT. ANY
ORGANIC MATE RIAL WILL INACTIVATE FORMALDEHYDE. DON'T USE GASTRIC
LAVAGE/EMETICS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:=60.C, 140.F
Lower Limits:7
Upper Limits:73
Extinguishing Media:CO2, DRY CHEMICAL/ALCOHOL FOAM
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES OF FORMALDEHYDE GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE CLOTHING & SELF CONTAINED
BREATHING APPARATUS/RESPIRATOR W/APPROVED NIOSH/MSHA CARTRIDGES.
CONTAIN & ABSORB W/INERT MATERIAL. SCOOP UP & PLACE IN APPROVED
HAZARDOUS WASTE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
Ventilation:MECHANICAL EXHAUST, FUME HOOD
Other Protective Equipment:PROTECTIVE APRON/GOWN
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH HANDS THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=98.C, 208.4F
Melt/Freeze Pt:=13.C, 55.4F
Vapor Density:1
Spec Gravity:1
Evaporation Rate & Reference:(ETHER=1): >1
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, PUNGENT ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROCHLORIC ACID, PERCHLORIC ACID
Hazardous Decomposition Products:FORMALDEHYDE GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:993 VARNISH
CAGE:5D028
CAGE:5D028
CAGE:71984
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 50.0%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2,6-CIS-DIPHENYLHEXAMETHYLCYCLOTETRASILOXANE.
Fraction by Wt: <.01%
ACGIH TLV:20MG/CUM.
Ingred Name:PHENYLHEPTOMETHYLCYCLOTETRASILOXANE
Fraction by Wt: <.01%
ACGIH TLV:200MG/CUM.
===================== Hazards Identification =====================
Effects of Overexposure:IRRITATES SKIN & EYES.MAY CAUSE SLIGHT
ANESTHESIA,HEADACHES,VAPORS MAY BE HARMFUL.
======================= First Aid Measures =======================
First Aid:FLUSH WITH WATER.INHAL:MOVE TO FRESH AIR.OBTAIN MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:80F CC.
Lower Limits:1.0.
Upper Limits:7.0.
Extinguishing Media:CARBON DIOXIDE OR FOAM.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL TO COLLECT & CONTAIN
FOR SALVAGE OR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:USE REASONABLE CARE.ORGANIC VAPOR
RESPIRATORS BE WORN BY OPERATING PERSONNEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC VAPOR TYPE
Ventilation:LOCAL EXHAUST RECOMMENDED
Other Protective Equipment:AS REQUIRED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:290F
Vapor Pres:10.
Vapor Density:>1.0
Spec Gravity:0.90.
Evaporation Rate & Reference:<1.0.
Solubility in Water:<0.1%.
Appearance and Odor:SOLVENT ODOR,LIQUID,SOME COLOR.
Percent Volatiles by Volume:>40.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDING MATERIAL
Hazardous Decomposition Products:SILICONE DIOXIDE,CO*2,TRACES OF
INCOMPLETE BURNED C PRODUCTS
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL LOCAL,STATE AND FEDERAL REGULATIONS
CONCERNING HEALTH & POLLUTION BE REVIEWED TO DETERMINE APPROVED
DISPOSAL PROCEDURES.CONTACT MANUFACTURER. IF THERE ARE ANY DISPOSAL
QUESTIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:985-P14 FLUORESCENT DYE PENETRANT
Preparer's Name:SHEREE L. KINZEL
CAGE:23373
CAGE:23373
============= Composition/Information on Ingredients =============
Ingred Name:WHITE MINERAL OIL
CAS:8042-47-5
RTECS #:PY8047000
Other REC Limits:NONE SPECIFIED
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY
PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038500
Other REC Limits:NONE SPECIFIED
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:AROMATIC NAPHTHA
CAS:64741-68-0
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES/SKIN:IRRITATION WITH
DELAYED EFFECTS. INHALATION:IRRITATION TO THROAT AND LUNGS.
INGESTION:NAUSEA, VOMITING, DIARRHEA AND UNCONSCIOUSNESS.
CHRONIC:NON SPECIFIC SYMPTOMS RELATED TO THE NERV OUS SYSTEM,
GASTROINTESTINAL SYSTEM ANDLUNGS MENTIONED BY MANUFACTURER.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:IRRITATION OF EYES/SKIN. NAUSEA AND VOMITING.
VOMITING MAY OCCUR SPONTANEOUSLY. DO NOT ALLOW VOMITUS TO BE
BREATHED INTOLUNGS (WILL CAUSE CHEMICAL PNEUMONITUS, PULMONARY
EDEMA/HEMORRHAGE. BLUISH SK IN, GAGGING, COUGHING, AND LABORED
BREATHINGARE INDICATIVE OF EXPOSURE. ANESTHETIC EFFECT IN HIGH
CONCENTRATIONS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN CONDITIONS MAY BE
SUSEPTIBLE TO THE EFFECTS OF COMPONENTS OF THIS PROODUCT.
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER. WASH SOILED
CLOTHING. INHALATION: REMOVE TO FRESH AIR. GIVE MOUTH-TO-MOUTH
RESUSCITAT ION IF NEEDED. KEEP VICTIM WARM AND GIVE OXYGEN IF
NEEDED. INGESTION: DO NOT INDUCE VOMITING. GIVE CONSCIOUS VICTIM
LOTS OF WATER. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Autoignition Temp:Autoignition Temp Text:428F
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT. USE WATER SPRAY TO COOL NEARBY
CONTAINERS EXPOSED TO FIRE BUT CAN CAUSE FROTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS. DENSE SMOKE MAY BE
GENERATED IN A FIRE. DO NOT SPRAY WATER ON CHEMICAL DIRECTLY
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT, ELIMINATE SOURCES
OF IGNITION, AND VENTILATE AREA AS REQUIRED. SMALL SPILLS MAY BE
ABSORBED WITH NON-COMBUSTIBLE INORGANIC MATERIAL. DIKE LARGE
SPILLS AND PREVENT RUNOFF TO SEWER/WATERWAYS. PLACE WASTE IN
APPROV. CONTAINER
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM SOURCES OF IGNITION. KEEP CONTAINER CLOSED.PROTECT
FROM PHYSICAL DAMAGE. KEEP FROM FREEZING.
Other Precautions:DO NOT REUSE STORAGE CONTAINERS FOR ANYTHING ELSE.
KEEP CONTAINERS TIGHTLY CLOSED. KEEP FROM DIRECT SUNLIGHT AND AWAY
FROM WELDING, GRINDING AND DRILLING ACTIVITIES. GROUND ALL
EQUIPMENT. DON'T USE AR OUND FOOD, DRINK OR WHEN SMOKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND
NIOSH-RESPIRATOR SELECTION. SCBA MAY BE NEEDED IN CONFINED AREAS.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS USUALLY ADEQUATE. SOME
USE MAY REQUIRE EXPLOSION-PROOF LOCAL VENTILATION.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. INDUSTRIAL TYPE
WORK CLOTHING AND APRON AS REQUIRED TO AVOID PROLONGED OR REPEATED
CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR DRINKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
MANUFACTURER RECOMMENDS THAT CONTACT LENSES NOT BE WORN WHEN USING THIS
PRODUCT.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>200F,>93C
Vapor Pres:<0.01
Vapor Density:6.72 AIR=1
Spec Gravity:0.8003
pH:UNKNON
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR YELLOW GREEN FLUORESCENT MOBILE LIQUID
Percent Volatiles by Volume:UNKNON
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING OR REDUCING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OPEN FLAMES,
IGNITION SOURCES
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE AND
OTHER POSSIBLE ORGANIC COMBUSTION PRODUCTS. ACRID SMOKE PRODUCED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. MANUFACTURER INDICATES USING
A SPECIALIST DISPOSAL COMPANY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FORMULA 117,COMPONENT II,MFR CODE 702701
CAGE:61196
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: >50%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:PHOSPHORIC ACID (SARA III)
CAS:7664-38-2
RTECS #:TB6300000
OSHA PEL:1 MG/M3/3 STEL
ACGIH TLV:1 MG/M3/3 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:ANESTHETIC,IRRIT OF RESP TRACT,ACUTE CNS
DEPR-HDACH,DIZZ,STAG.GAIT,CONFUSN,UNCON,COMA.SKIN/EYE IRRIT
======================= First Aid Measures =======================
First Aid:FLUSH EYES IMMEDIATELY W/WATER FOR 15 MIN.FLUSH SKIN W/WATER
WHILE REMOVING CONTAMINATED CLOTHING.IF INHALED,REMOVE TO FRESH
AIR. CALL MD IF SUMPTOMS PERSIST.
===================== Fire Fighting Measures =====================
Flash Point:62F TCC
Lower Limits:2.50
Extinguishing Media:CO*2,DRY CHEM.ALCOHOL FOAM. POLYMER FOAM FOR LARGE
FIRES.
Fire Fighting Procedures:IF H*2O USED FOG NOZZLE PREFERABLE.COOL CLOSD
CONTNRS W/H2O.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS CLOSED.ISOLATE FROM
IGNITION SOURCES. CONTAINERS EXPOSED TO EXTREME HEAT MAY EXPLODE
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES,HOT
SURFACES, & ELECTRICAL,STATIC,OR FRICTIONAL SPARKS). AVOID
BREATHING VAPORS.VENTILATE AREA. REMOVE W/INERT ABSORBENT &
NON-SPARKING TOOLS
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT APPLY TO VERY HOT SURFACES.DO
NOT STORE ABOVE 120F. STORE LARGE QTYS IN BLDG DESIGNED TO COMPLY
W/OSHA 1910.106.
Other Precautions:CONTAINERS SHOULD BE GROUNDED WHEN POURING.AVOID FREE
FALL OF LIQUID IN EXCESS OF A FEW INCHES.DONT FLAME CUT,BRAZE OR
WELD COATED MATERIAL W/O APPROVED RESPIRATOR OR APPROPRIATE
VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD RESPIRATORY PROTECTION FOR
EXPOSURE OF CONCERN
Ventilation:PROVIDE GENL DILUTN OR LOCAL EXHAUST TO KEEP TLV BELOW
LIMIT
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT TO
CONTAMINATED CLOTHING.
Supplemental Safety and Health
KEY1:F6.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:175 TO 212F
Vapor Density:>1
Evaporation Rate & Reference:<1 ETHER
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW LOCAL,STATE & FED REGS.INCINERATE IN
APPROVED FACILITY.DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AMMONIUM HYDROXIDE
Preparer's Name:DGSC-SHH
CAGE:EO204
CAGE:EO204
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM HYDROXIDE (SARA III)
CAS:1336-21-6
RTECS #:BQ9625000
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS 350 MG/KG. (RTECS)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- HARMFUL IF SWALLOWED/INHALED. EXTREMELY
DESTRUCTIVE TO TISSUE OF MUCOUS MEMBRANES & UPPER RESPIRATORY
TRACT, EYES & SKIN. INHALATION MAY BE FA TAL DUE TO SPASM,
INFLAMMATION & EDEMA OF LARYNX & BRONCHI. MAY CAUSE BLINDNESS.
CHRONIC- NONE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:CORROSIVE TO EYES, SKIN AND MUCOUS MEMBRANES,
IRRITATION OF EYES, SKIN, RESPIRATORY TRACT, ABDOMINAL PAIN,
NAUSEA, VOMITING, COUGHING
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IMMEDIATELY. EYE/SKIN:IMMEDIATELY FLUSH
WITH WATER FOR AT LEAST 15 MINUTES. HOLD EYELIDS OPEN.
INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF NEEDED. ORAL:DO
NOT INDUCE VOMI TING. IF CONSCIOUS, DRINK LARGE AMOUNT OF
WATER/MILK. CALL A PHYSICIAN IMMEDIATELY. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:16.0 VAPOR
Upper Limits:25.0 VAPOR
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER SPILL WITH SOLID NEUTRALIZER OR
ABSORBER. PUT NEUTRALIZED MATERIAL IN LINED DISPOSAL CONTAINER.
FLUSH RESIDUE WITH WATER.
Neutralizing Agent:BORIC ACID, DILUTE ACETIC ACID.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, VENTILATED AREA. KEEP
CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT CONTAINERS FROM
PHYSICAL DAMAGE. WORK IN A HOOD.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE VAPORS. AVOID
CONTACT WITH EYES AND SKIN. WASH THOROUGHLY AFTER HANDLING. KEEP
OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE IN WELL VENTILATED AREA (HOOD). ALWAYS USE
NIOSH APPROVED RESPIRATORS WHEN REQUIRED.
Ventilation:ADEQUATE
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
MANUFACTURER UNKNOWN. THIS MSDS WAS PREPARED BY THE PROFESSIONALS OF
DGSC-SHH WITHOUT ANY WARRANTY. IT IS THE USER'S RESPONSIBILITY TO
GATHER INFORMATION AND USE THE MATERIAL PROPERLY TO PROTECT EMPLO
YEES AND ENVIRONMENT.
================== Physical/Chemical Properties ==================
HCC:C2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:80.6F,27.0C
Vapor Density:<1
Spec Gravity:0.88
Solubility in Water:COMPLETE
Appearance and Odor:WATER WHITE LIQUID, STRONG ,PUNGENT AMMONIA ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS
Stability Condition to Avoid:HIGH HEAT
Hazardous Decomposition Products:AMMONIA GASES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HORPU SILANFESTIR
CAGE:HARPA
CAGE:HARPA
============= Composition/Information on Ingredients =============
Ingred Name:WHITE SPIRIT
RTECS #:ZC3850000
ACGIH TLV:200 PPM (MFR)
Ingred Name:SOLVENT NAPHTA
ACGIH TLV:100 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: DIZZINESS, NAUSEA, HEADACHE.
SKIN: CAN CAUSE DEFATTING AND DERMATITIS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SKIN: WASH WITH SOAP AND WATER.
INGEST: DO NOT INDUCE VOMIT. GET MED AID. EYES: IMMED FLUSH WITH
POTABLE WATER FOR A MINIMUM OF 15 MIN, SEEK ASSISTANCE FROM MD .
===================== Fire Fighting Measures =====================
Flash Point:>77F,>25C
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . DO NOT USE WATER.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:USE SPARK PROOF TOOLS. ELIMINATE IGNITION
SOURCES. ADD ABSORBENT. TRANSFER TO APPROPRIATE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT SHOULD BE KEPT COOL AND STORED
IN WELL VENTILATED ROOMS, PROTECTED AGAINST HEAT AND DIRECT
SUNLIGHT. CONTAINER MUST BE KEPT TIGHTLY CLOSED.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED VAPOR MASK, AS REQUIRED
FOR MINERAL SPIRITS.
Ventilation:LOCAL EXHAUST/MECHANICAL(GENERAL): REQUIRED.
Other Protective Equipment:CLEAN BODY COVERING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:293F,145C
Vapor Density:>1
Spec Gravity:0.82
Solubility in Water:NO
Appearance and Odor:CLEAR LIQUID WITH SOME ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
Conditions to Avoid Polymerization:EXCESSIVE HEAT, OPEN FLAME, SPARKS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION, OR OTHERWISE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: CITRIC ACID, ANHYDROUS
Cage: 75656
=======================================================
Contractor Summary
=======================================================
Cage: 75656
Box: 1987
=======================================================
Ingredients
=======================================================
Cas: 77-92-9
RTECS #: GE7350000
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 5949-29-1
RTECS #: GE7810000
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
% Wt: TRACE
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
% Wt: TRACE
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 7440-38-2
RTECS #: CG0525000
% Wt: TRACE
OSHA PEL: SEE 1910.1018
ACGIH TLV: 0.01 MG/M3, A1
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 1309-37-1
RTECS #: NO7400000
% Wt: TRACE
OSHA PEL: 10 MG/M3 (FE)
ACGIH TLV: 5 MG(FE)/M3 FUME, B2
------------------------------
% Wt: TRACE
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
% Wt: TRACE
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
MAY FERMENT UPON STANDING TO FORM
-----------------------------
-----------------------------
COPPER, ZINC, ALUMINUM & THEIR ALLOYS.
-----------------------------
ANYTHING BY MOUTH TO UNCON OR CONVULSING
-----------------------------
CONSCIOUS & ALERT PERSON DRINK 1-2
-----------------------------
IN-PLANT, PARAMEDIC/COMMUNITY MED
-----------------------------
-----------------------------
PVNT ENTRY INTO SEWERS, DRAINS, &
-----------------------------
-----------------------------
GRAS(GENERALLY RECOGNIZED AS SAFE) LIST FOR FOOD
-----------------------------
POWDER.
-----------------------------
N).
-----------------------------
CONTROLLING IT AT ITS SOURCE.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50: (ORAL,RAT) 6.7 G/KG
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: CITRIC ACID IS MODERATELY IRRITATING TO SKIN &
SEVERELY IRRITATING TO EYES. DUST INHAL MAY CAUSE MINOR RESP TRACT IRRIT
& COUGH. THROUGH ITS USE AS AN ANTICOAGULANT FOR BLOOD DURING SURGERY, CI
TRIC ACID WAS FOUND TO BE A NATURAL CHELATING AGENT CAPABLE OF DECREASING THE
ABSORPTION OF IRON AND (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: CALCIUM. HYPOCALCEMIA (CALCIUM
DEFICIENCY IN BLOOD) MAY RESULT IN SEVERE CASES OF INGESTION. CHRONIC:
CHRONIC OR HEAVY ACUTE INGESTION MAY CAUSE TOOTH ENAMEL EROSION. TARGET
ORGANS: EYES, SK IN, RESPIRATORY TRACT.
Medical Cond Aggravated By Exposure: NONE REPORTED.
First Aid: EYE: DO NOT ALLOW VICTIM TO RUB/KEEP EYES TIGHTLY SHUT. GENTLY LIFT
EYELIDS & FLUSH IMMED & CONTINUOUSLY FOR @ LST 15 MINS W/FLOODING
AMTS OF WATER UNTIL TRANSPORTED TO EMER MED FACILITY. CONSULT PHYS IMMED.
SKIN: QUICKLY REMOVE CONTAMD CLTHG. RINSE W/FLOODING AMTS OF WATER FOR @ LST
15 MINS. WASH EXPOS AREA W/SOAP & WATER. FOR REDDENED/BLISTERED SKIN,
CONSULT PHYS. INHAL: REMOVE TO FRESH
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NOTIFY SFTY PERS, ISOLATE & VENTILATE AREA, DENY
ENTRY. & STAY UPWIND. SHUT OFF ALL IGNIT SOURCES. CLEANUP PERS SHOULD
PROTECT AGAINST DUST INHAL & SKIN/EYE CONT. DO NOT SWEEP UP SM SPILLS;
WET DOWN & SCOOP ONTO SUITABLE CNTNRS FOR DISPOSAL.
Neutralizing Agent: LIME CAN BE ADDED TO NEUT & PRECIPITATE CALCIUM CITRATE
FROM SOLUTION SPILLS.
Waste Disposal Methods: INJECT WASTE @ BASE OF INCINERATOR EQUIPPED WITH
AFTERBURNER. CONT SUPPIER OR LICENSED CONTRACT FOR DETAILED RECOMMENDATIONS.
FOLLOW APPLICABLE FEDERAL, STATE, AND LOCAL REGULATIONS.
Handling And Storage Precautions: PVNT PHYSICAL DMG TO CNTNRS. STORE IN COOL,
DRY, WELL-VENTILATED AREA AWAY FROM HEAT, IGNIT SOURCES & INCOMPATS.
REMOVE MATL FROM SHOES & CLEAN PPE.
Other Precautions: DO NOT STORE IN CNTNRS MADE OF COPPER, ALUMINUM/THEIR
ALLOYS. ADMINISTRATIVE CTLS: CONSIDER PREPLACEMENT & PERIODIC MED EXAMS
OF EXPOS WORKERS. SEPARATE CONTAMD WORK CLTHES & STREET CLOTHES &
LAUNDER BEFORE RESUE. CITRIC ACID IS
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: COMBUSTIBLE
Lower Limits: X
Upper Limits: X
Extinguishing Media: FIGHT FIRE WITH DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY,
OR REGULAR FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). DO NOT RELEASE RUNOFF FROM FIRE CONTROL METHODS TO
SEWERS/WATERWAYS/ DIKE FOR PROPER DISPOSAL.
Unusual Fire/Explosion Hazard: WHEN IN FINELY DIVIDED POWDER FORM, CITRIC ACID
IS AN EXPLOSION HAZARD.
=======================================================
Control Measures
=======================================================
Respiratory Protection: SEEK PROFESSIONAL ADVICE PRIOR TO RESP SELECTION &
USE. FOLLOW OSHA RESP REGS (29 CFR 1910.134) &, IF NEC, WEAR NIOSH APPRVD
RESP. USE OF NIOSH APPRVD DUST MASK SHOULD BE SUFFICIENT FOR PROT AGAINST I
NHAL OF CITRIC ACID
Ventilation: PROVIDE GEN & LOC EXHAUST VENT SYS TO MAINTAIN AIRBORNE CONCS
AS LOW AS POSS. LOC EXHAUST VENT IS PREF SINCE
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N). BOOTS,
APRONS, & GAUNTLETS TO PVNT IRRIT FROM SKIN CONTACT.
Work Hygienic Practices: NEVER EAT, DRINK/SMOKE IN WORK AREAS. PRACTICE GOOD
PERSONAL HYGIENE AFTER USING MATERIAL.
Supplemental Safety and Health: BP: DECOMPOSES. 212F(100C). PH: (0.1 N SOLN):
2.2. SOL IN H*2O: VERY SOLUBLE; 59% (68F/20C), 68.6% @ (104F/40C), 73.5% @
(140F/60C), 78.8% @ (176F/80C), 84% @ (212F/100C). APPEAR/ODOR: CRYSTALLINE
POW DER WITH A STRONG ACIDIC TASTE. ABSORBSMOISTURE READILY FROM AIR.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: DECOMPOSES
M.P/F.P Text: 307F,153C
PH: SUPDAT
Evaporation Rate & Reference: NOT KNOWN
Solubility in Water: SUPP DATA
Appearance and Odor: ODORLESS, COLORLESS, TRANSLUCENT CRYSTALS OR WHITE
GRANULES TO FINE (SUPDAT)
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: DISPERSING POWDER IN AIR, CONT W/COMPATIBLES, AND
EXPOSURE TO HEAT AND IGNITION SOURCES. ANHYDROUS CITRIC ACID
Materials To Avoid: INCL POTASSIUM TARTRATE, ALKALI & ALKALINE EARTH CARBONATES
& BICARBONATES, ACETATES, SULFITES, & METAL NITRATES
Hazardous Decomposition Products: THERMAL OXIDATIVE DECOMP OF CITRIC ACID CAN
PRDCE ACRID, IRRITATING SMOKE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: CITRIC ACID, ANHYDROUS
Cage: 75656
Company Name: LOS ANGELES CHEMICAL CO
Street: 4545 ARDINE ST
PO Box: 1987
Zipcode: 90280
Label Required IND: Y
Date Of Label Review: 04/15/1998
Status Code: C
Label Date: 04/15/1998
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: SKIN: MODERATE IRRITATION. EYES:
SEVERE IRRITATION. INHALATION: MINOR RESPIRATORY TRACT IRRITATION. CHRONIC:
CHRONIC OR HEAVY ACUTE INGESTION MAY CAUSE TOOTH ENAMEL EROSION.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LATEX COVE BASE ADHESIVE 3130
CAGE:16882
CAGE:16882
============= Composition/Information on Ingredients =============
Ingred Name:BENZIN; (BLEND OF MINERAL SPIRITS). LD50:(ORAL RAT) 0.5-5
G/KG
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 5%
Ingred Name:ETHYLENE GLYCOL (SARA III). LD50:(ORAL RAT) 8540 MG/KG
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 1%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM, VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LATEX, (INERT INGREDIENTS)
Ingred Name:VOLATILE ORGANIC COMPOUNDS (90 GRAMS/LITRE)
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: VAPOR MAY CAUSE IRRIT OF EYES,
SKIN & RESP TRACT. MAY CAUSE CNS DEPRESS; HDCH, DIZZ, NAUS OR
UNCON. SKIN CHAPPING MAY OCCUR AFTER PRLNGD SKIN EXPOS. IF INGESTED
CAUSES VOM, DIARR & DEPRESSED RE SPIRATION. CHRONIC: PRLNGD/RPTD
CONT W/SKIN CAN CAUSE DRYING/ CHAPPING OF SKIN. A NUMBER OF STUDIES
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SUPPLIED BY OUR TRADE ASSOCIATION HAVE
INDICATED THAT CONTINUAL OVEREXPOSURE TO CONCENTRATED SOLVENT VAPOR
OVER A PERIOD OF TIME MAY LEAD TO PERMANENT CNS DAMAGE.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS &
IMPAIRED PULMONARY FUNCTIONS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR; RESTORE BREATHING IF NECESSARY.
CONTACT MD. EYES:FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINS. CONTACT MD. SKIN:WASH W/SOAP & WATER. CONSULT MD IF
IRRITATION DEVELOPS . INGEST:DO NOT INDUCE VOMITING. IF VICTIM IS
CONSCIOUS, GIVE WATER OR MILK. CONTACT MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Extinguishing Media:FOAM, CARBON DIOXIDE OR DRY CHEMICALS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . DO NOT USE STRAIGHT HOSE WATER STREAM. COOL
EXPOSED CONTAINER W/WATER.
Unusual Fire/Explosion Hazard:CONTRS MAY EXPLODE IF EXPOSED TO EXTREME
HEAT; ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS & OPEN
FLAMES. DO NOT PUT IN CONTACT W/OXIDIZING MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL:USE ABSORB MATL OR SCAPE UP DRIED MATL &
PLACE INTO CONTRS. LGE:WEAR PROT EQUIP. ELIM ALL SOURCES OF IGNIT
(OPEN FLAMES/PILOT LIGHTS/ELEC SPRKS) & VENT SPILL AREA. CONTAIN
SPILL BY DIKING TO PVN T SPREADING. USE ABSORB MATL OR SCRAPE (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTRS FROM EXCESSIVE HEAT &
FREEZING. PROVIDE CROSS VENTILATION IN STORAGE AREA. KEEP CONTRS
TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID PROLONGED OR
REPEATED BREATHING OF VAPORS & CONTACT W/SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF 8-HR EXPOSURE LIMIT OR VALUE IS EXCEEDED FOR
ANY COMPONENT, USE A NIOSH/MSHA APPROVED RESPIRATOR. CONSULT YOUR
SAFETY EQUIPMENT SUPPLIER & OSHA REG 29CFR1910.134.
Ventilation:PROVIDE SUFFICIENT MECHANICAL VENTILATION (LOCAL OR GENERAL
EXHAUST) TO MAINTAIN EXPOSURE BELOW LIMITS & VALUES.
Other Protective Equipment:PROVIDE EYEWASH & SOLVENT IMPERVIOUS APRON
IF BODY CONTACT WITH PRODUCT MAY OCCUR.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL PROC:UP DRIED MATERIAL & PLACE INTO CONTAINERS. PREVENT RUN-OFF
TO SEWERS, STREAMS, LAKES OR OTHER BODIES OF WATER; NOTIFY LOCAL
HEALTH & WILDLIFE OFFICIALS IF RUN-OFF OCCURS.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>310F,>154C
Vapor Pres:2 @ 20C
Vapor Density:4.0
Evaporation Rate & Reference:0.6 (TOLUENE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT BROWN ADHESIVE; SLIGHT SOLVENT ODOR.
Percent Volatiles by Volume:5-10
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:NORMAL COMBUSTION PRODUCTS, I.E. COX &
NOX.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARDED SPILL RESIDUE MAY BE INCINERATED. DO
NOT INCINERATE SEALED CONTAINERS. DISPOSE ACCORDING TO FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SINGLE-STRIKE BLACK CORRECTABLE TYPEWRITER
CAGE:0E6G9
CAGE:0E6G9
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE, POLYMERS, PYROLYZATE; (HIGH DENSITY COATED
POLYOLEFIN FILM)
CAS:9002-88-4
RTECS #:KX3270000
Fraction by Wt: >95%
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:POLYAMIDE RESIN
CAS:68154-56-3
Ingred Name:MINERAL OIL
CAS:8012-95-1
RTECS #:PY8030000
Ingred Name:STEARIC ACID, BUTYL ESTER; (BUTYL STEARATE)
CAS:123-95-5
RTECS #:WI2900000
Fraction by Wt: <5%
ACGIH TLV:10 MG/M3
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SILICON DIOXIDE, AMORPHOUS; (SILICON DIOXIDE)
CAS:7631-86-9
OSHA PEL:6 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE MINIMAL IRRITATION TO EYES
OR SKIN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN:WASH WITH
SOAP AND WATER. INHAL:NOT APPLICABLE. REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE O*2/ARTIFICIAL RESPIRATION) . INGEST:NOT APPLICAB
LE. CALL MD IMMEDIATELY . FURTHERINFORMATION ON FILE IN POISINDEX.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . AVOID BREATHING PRODUCTS OF DECOMPOSITION.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:NONE REQUIRED WHEN USED AS INTENDED IN XEROX EQUIPMENT.
Other Protective Equipment:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:RIBBON, 8R3648.
================== Physical/Chemical Properties ==================
Vapor Pres:0 (H*20=1)
Vapor Density:0 (AIR=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RIBBON CARTRIDGE WITH MINIMAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:IN A FIRE, CO, CO*2, PHOSGENE AND
OTHER TOXIC PRODUCTS OF DECOMPOSITION MAY BE EVOLVED.
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIAL DISPOSAL METHOD REQUIRED. DISPOSE OF
IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COBALT OXIDE, ACC05294
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:COBALT OXIDE
CAS:1308-06-1
RTECS #:GG2500000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:ASTHMA & PNEUM. SYMPS MAY INCL WHEEZING, NASAL
OBSTRUCTION, SNEEZING, ANOREXIA & WEIGHT LOSS, HEADACHE, (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:CHANGES IN ELECTRICAL ACTIVITY OF BRAIN & AN INCR
INCIDENCE OF SPONT ABORTIONS. SKIN:PRLNGD CONT MAY LEAD (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:TO SENSIT/PHOTOCONTACT DERM. INGEST:CARDIOMYOPATHY
HAS BEEN CAUSED BY EXCESS INTAKE OF COBALT. SIGNS & (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:SYMPS OF THIS ILLNESS INCL GI DISTURB W/NAUS, VOMIT &
DIARR, DYSPNIA DRY & PERSISTENT COUGH. THORACID & (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:RIGHT UPPER QUADRANT ABDOM PAIN, ANKLE EDEMA
CYANOSIS, HYPOTENTIONS, HEART ENLARGEMENT, PERICARDIAL (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:EFFUSION, ECG ABNORMALITIES, TACHYPNEA & DEATH. FOR
MORE DETAILED HEALTH HAZARD INFORMATION CONT NEHC .
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:UPPER & LOWER LIDS, UNTIL NO EVID OF CHEM
REMAINS (FOR @ LST 15 MINS). GET MED ATTN IMMED. (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:INGEST:TREAT SYMPTOMATICALLY & SUPPORTIVELY. GET MED
ATTN IMMED IF VOMIT OCCURS. KEEP HEAD LOWER THAN HIPS(ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:TO PVNT ASPIR. ANTIDOTE:GIVE CALCIUM DISODIUM EDETATE
AVAIL AS 5 ML AMPULES OF 20% SOLN. GIVE 15-25 MG/KG (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:(0.08-0.125 ML OF 20% SOLN PER KILOGRAM OF BODY WT)
IN 250-500 ML OF 5% DEXTROSE INTRAVENOUSLY OVER A 1-2(ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:HR PERIOD. TWICE DAILY MAXIMUM DOSE SHOULD NOT
EXCEED 50 MG/KG/DAY. THE DRUG SHOULD BE GIVEN IN 5 DAY (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:COURSES W/REST PERIOD OF @ LST 2 DAYS BETWEEN
COURSES AFTER FIRST COURSE. SUBSEQUENT COURSE SHOULD NOT (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:EXCEED 50 MG/KG/DAY. DAILY URINALYSES SHOULD BE DONE
DURING TREATMENT PERIOD. DOSAGE SHOULD BE REDUCED (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:IF ANY UNUSUAL URINARY FINDINGS APPEAR. FOR
INTRAMUSCULAR ADMIN GIVE 20% SOLN (200 MG/ML) 12.5 MG/KG (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:BODY WT EVERY 4-6 HRS. DILUTE EACH DOSE W/EQUAL
VOLUME OF 1% PROCAINE. DOSE LIMITATION IS SAME AS THAT (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:GIVEN ABOVE. FOR SEV INTOXICATION, SOME EXPERTS URGE
SIMULTANEOUS ADMIN OF DIMERCAPROL DURING FIRST 48 (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:HRS OF TREATMENT. ANTIDOTE SHOULD BE ADMINISTERED BY
QUALIFIED MED PERS. GET MED ATTN IMMED.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:MIST FILTER. 2.5 MG(CO)/M3-ANY AIR PURIFYING FULL
FACEPEICE RESP W/HIGH EFFICIENCY PARTICULATE FILTER.(ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:20 MG(CO)/M3-ANY SUPPLIED AIR RESP THAT HAS FULL
FACEPIECE & IS OPERATED IN PRESS DEMAND/OTHER POS PRESS MODE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 5 GMKG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:20 MG(CO)/M3 IMMED
DANGEROUS TO LIFE/HLTH. MAY CAUSE UPPER RESP TRACT IRRIT, RHINITIS
& TRACHEITIS. SENSIT RXNS MAY OCCUR IN PREVIOUSLY EXPOS PERSONS. IN
ANIMALS, INHAL OF COBALT SALTS HASCAUSED PULM EDEMA. METAL FUME
FEVER ANINFLUENZA LIKE ILLNESS MAY OCCUR DUE TO INHAL OF FRESHLY
FORMED(EFTS OF OVEREXP)
Explanation of Carcinogenicity:COBALT OXIDES:IARC MONO ON EVAL OF
CARCIN RISK OF CHEMS TO MAN V 52, P 363, 1991:GROUP 2B. ANIMAL
MUSCULOSKELETAL TUMOR.
Effects of Overexposure:HLTH HAZ:METAL OXIDE PARTICLES SIZED BELOW 15
MICRONS & USUALLY BETWEEN 0.02-0.05 MICRONS SYMPS MAY BE DEALYED
4-12 HRS & BEGIN W/SUDDEN ONSET OF THIRST & SWEET METALLIC/FOUL
TASTE IN MOUTH. OTHER SYM PS MAY INCL UPPER RESP TRACT IRRIT,
COUGH, DRYNESS OF MUC MEMB, FEVER, CHILLS, HDCH, NAUS, VOMIT.
SKIN:MAY (SUPDAT)
Medical Cond Aggravated by Exposure:PERSONS WITH PRE EXISTING
RESPIRATORY OR SKIN DISEASE.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR IMMED. IF BRTHG STOPPED, PERFORM
ARTF RESP. KEEP WARM & @ REST. TREAT SYMPOTOMATICALLY &
SUPPORTIVELY. GET MED ATTN IMMED. SKIN:REMOVE CONTAMD CLTHG & SHOES
IMMED. WASH AFFEC TED AREA W/SOAP OR MILD DETERGENT & LG AMTS OF
WATER UNTIL NO EVID OF CHEM REMAINS (APPROX 15-20 MINS). GET MED
ATTN IMMED. EYE:WASH IMMED W/LG AMTS OF WATER/NORM SALINE. OCCASNLY
LIFTING (ING 8)
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINGUISH USING AGENT SUITABLE FOR TYPE OF
SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NO ACUTE HAZ. MOVE CNTNR FROM FIRE AREA IF POSSIBLE.
AVOID BRTHG VAPS/DUSTS. KEEP UPWIND.
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE HAZARD WHEN EXPOSED TO
HEAT OR FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:FOR LG SPILLS, SWEEP UP W/MINIMUM OF DUSTING &
PLACE INTO SUITABLE CLEAN, DRY CNTNRS FOR RECLAMATION OR LATER
DISPOSAL. RESIDUE SHOULD BE CLEANED UP USING HIGH EFFICIENCY
PARTICULATE FILTER VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINER.
STORE AT CONTROLLED ROOM TEMPERATURE. STORE AWAY FROM INCOMPATIBLE
SUBSTANCES.
Other Precautions:PREVENT DISPERSION OF DUST IN AIR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPS MUST BE NIOSH APPRVD. 0.25 MG(CO)/M3-ANY
DUST & MIST RESP. 0.5 MG (CO)/M3-ANY DUST & MIST RESP EXCEPT SINGLE
USE & QUARTER MASK RESPS. ANY SUPPLIED AIR RESP. ANY SCBA.
1.25MG(CO)/M3-ANY POWDEREDAIR PURIFYING RESP W/DUST & (ING 19)
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION SYSTEM TO MEET PUBLISHED
EXPOSURE LIMTIS.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
CLOTHING & EQUIPMENT TO PVNT SKIN CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:CAUSE IRRIT . SENSIT DERM MAY OCCUR IN PERSONS WHO HAVE
BEEN PREVIOUSLY EXPOSED. EYE:COBALT DUST MAY BE IRRITATING.
INGEST:VOMIT, DIARR, SENSATION OF HOTNESS, MILD HYPOTENSION, RASH,
T INNITUS, & NERVE DEAFNESS MAY OCCUR AFTER INGEST OF LG AMTS.
CHRONIC:INHAL:PRLNGD EXPOS MAY CAUSE EXTRINSIC (ING 2)
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>1652F,>900
Spec Gravity:6.07
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK OR GRAY, HYGROSCOPIC. CUBIC CRYSTALLINE
POWDER OR SOLID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROGEN PEROXIDE, NITROETHANE, NITROMETHANE, NITROPHOPANE, OXIDIZERS
(STRONG) INCOMPATIBLE.
Stability Condition to Avoid:PREVENT DISPERSION OF DUST IN AIR.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE TOXIC OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:OBSERVE ALL FEDERAL, STATE AND LOCAL REGULATIONS
WHEN STORING OR DISPOSING OF THIS SUBSTANCE.
| 1 | gloves_mandatory |
Subsets and Splits